Scribd Logo
Upload

Welcome to Scribd!

  • 184 views

    NTPC Anta Combined Cycle

    Uploaded by

    Siyaram Meena
    This document provides an overview of the NTPC Anta combined cycle power plant located in Rajasthan, India. It details that the plant has a total installed capacity of 419MW generated from 3 gas turbine generators and 1 steam turbine generator. It also describes the plant's fuel supply, water source, and some of the key components and systems used in its power generation process.

    Copyright:

    © All Rights Reserved
    Download as PPT, PDF, TXT or read online from Scribd

    NTPC Anta Combined Cycle

    Uploaded by

    Siyaram Meena
    184 views25 pages
    This document provides an overview of the NTPC Anta combined cycle power plant located in Rajasthan, India. It details that the plant has a total installed capacity of 419MW generated from 3 gas turbine generators and 1 steam turbine generator. It also describes the plant's fuel supply, water source, and some of the key components and systems used in its power generation process.

    Original Description:

    ntpc anta combined cyclepower plant ppt

    Original Title

    3. Ntpc Anta Combined Cycle

    Copyright

    © © All Rights Reserved

    Available Formats

    PPT, PDF, TXT or read online from Scribd

    Did you find this document useful?

    Is this content inappropriate?

    This document provides an overview of the NTPC Anta combined cycle power plant located in Rajasthan, India. It details that the plant has a total installed capacity of 419MW generated from 3 gas turbine generators and 1 steam turbine generator. It also describes the plant's fuel supply, water source, and some of the key components and systems used in its power generation process.

    Copyright:

    © All Rights Reserved
    Download as PPT, PDF, TXT or read online from Scribd
    Download as ppt, pdf, or txt
    184 views25 pages

    NTPC Anta Combined Cycle

    Uploaded by

    Siyaram Meena
    This document provides an overview of the NTPC Anta combined cycle power plant located in Rajasthan, India. It details that the plant has a total installed capacity of 419MW generated from 3 gas turbine generators and 1 steam turbine generator. It also describes the plant's fuel supply, water source, and some of the key components and systems used in its power generation process.

    Copyright:

    © All Rights Reserved
    Download as PPT, PDF, TXT or read online from Scribd
    Download as ppt, pdf, or txt
    of 25

    INTRODUCTION

    NTPC ANTA
    A COMBINED CYCLE POWER PLANT

    RAJENDRA JAT
    DEPUTY MANAGER
    (EMD)
    6 June 2018 1
    NTPC ANTA

    6 June 2018 INSTALLED CAPACITY – 419MW 2


    NTPC LTD
    • A MAHARATNA COMPANY
    • TOTAL INSTALLED CAPACITY- 47178MW
    • 44 STATIONS
    • THERMAL POWER PLANT- 35085MW
    • GAS BASED POWER PLANT- 4017MW
    • HYDRO POWER PLANT – 800MW
    • SOLAR PLANTS – 310MW
    • JOINT VENTURES– 6966MW

    6 June 2018 PMI Revision 00 3


    PLF OF NTPC STATION VS ALL INDIA

    6 June 2018 4
    NTPC ANTA- Brief
    Introduction
    • INSTALLED IN 1989 (NTPC’S FIRST GAS BASED
    POWER PLANT)
    • COMBINED CYCLE POWER PLANT
    • DUAL FUEL- NATURAL GAS & NAPTHA
    • TOTAL INSTALLED CAPACITY- 419 MW
    • NTPC’S ONLY POWER PLANT IN RAJASTHAN
    • FUEL SUPPLY – GAIL (HVJ Pipe Line)
    • WATER- CHAMBAL (Right Main Canal)

    6 June 2018 5
    Gas Turbine Generators (GT’s)

    •Total No of GT’s @ NTPC Anta- 3

    •Installed Capacity per GT- 88.71 MW (Standard


    Atmospheric Conditions)

    •Out Put Voltage of Gas Turbine Generator-


    10.5 kV

    •Secondary Voltage of Generator Transformer -


    220kV

    •Concept of Generator Circuit Breaker- To


    isolate Generator form Generator Transformer
    6 June 2018 6
    •Unit Auxiliary Transformers – for unit
    Auxiliaries

    •Starting of Generator as Synchronous


    Motor- Starting Equipment

    •Starting Equipment - Static Frequency


    Converter (ONLY IN 2 GT’S)

    •3000 RPM REACHED IN APPROX 6 MINUTES

    •FIRING IN CC STARTS @ 800 rpm &


    STATING EQUIPMENT CUT OUT @ 2000 rpm

    6 June 2018 7
    GENERATION COST FOR NTPC ANTA
    GENERATION COST VARIES WITH TYPE OF FUEL

    •APM+PMT – 2.30 RS/ UNIT

    •RLNG (SPOT & TRENCH) – 6 TO 8 RS/UNIT

    •NAPTHA – 9 TO 10 RS/UNIT

    •GENERATION COST INCREASES WHEN PLANT


    RUNS IN OPEN CYCLE (WHRB’S ARE NOT IN
    USE)

    6 June 2018 8
    Combined Cycle Power Plant

    6 June 2018 9
    Unit Auxiliary
    Transformer

    Gas Generator Transfor Isolator Grid


    Turbine Circuit mer Circuit
    Generator Breaker 10.5kV/22 Breaker
    10.5kV 0kV

    6 June 2018 10
    WEST HEAT RECOVERY BOILER (WHRB)
    VERTICAL NON FIRED BOILER

    WATER & STEAM IN PIPES

    TEMPERATURE OF EXHAUST GAS AT BOTTOM – 500


    DEGREE

    DM WATER & SUPER HEATED STEAM CYCLES - 2

    HIGH PRESSURE HIGH TEMPERATURE - @ BOTTOM


    LOW PRESSURE LOW TEMPRETURE - @ TOP

    EXHAUST GAS TEMPERATURE @ TOP OF WHRB – 100


    DEGREE
    6 June 2018 PMI Revision 00 11
    6 June 2018 12
    Steam Turbine Generators (STG)
    •Total No of STG @ NTPC Anta- 1

    •Installed Capacity STG- 153MW (Full Load)

    •Out Put Voltage of Gas Turbine Generator- 15.5 kV

    •Secondary Voltage of Generator Transformer - 220kV

    •Steam Turbine – HP Turbine & LP Turbine

    •HP Steam Pressure (60-70 Bar) & Temperature (500


    Degree Centigrade)

    •LP Steam Pressure (4-5 Bar) & Temperature (240


    Degree Centigrade)

    6 June 2018 PMI Revision 00 13


    POWER TRANSFORMER PARTS
    1. TRANSFORMER HV & LV WINDINGS
    2. TRANSFORMER OIL
    3. CONSERVATOR TANK
    4. HV & LV BUSHING
    5. BREATHER
    6. OIL TEVEL INDICATOR
    7. WINDING & OIL TEMPERATURE INDICATOR
    8. BUCHHOLZ RELAY
    9. TERMINAL BOX
    10.PRESSURE RELIEF DEVICE
    11.TAP CHANGER
    12.RADIATORS

    6 June 2018 14
    6 June 2018 PMI Revision 00 15
    GENERATOR ROTOR

    6 June 2018 16
    Factors Affecting Output of Gas Power
    Plants

    Ambient Temperature- Gas Turbine Output MW


    decreases with Increase in Ambient
    Temperature

    Ambient Humidity – Output MW increases with


    increase in Humidity

    Steam Turbine Output depends on steam


    parameters

    6 June 2018 PMI Revision 00 18


    GT POWER(29.5 %)

    EXHAUST
    FUEL GAS
    (100 %) TURBINE HEAT
    (67 %)

    MISC.
    (3.5 %)

    OPEN CYCLE GAS TURBINE


    Energy Balance

    6 June 2018
    C:\UMESH\DEPT\GTDRG01.PPT....005 19
    TOTAL POWER 45% (GT=29.5 % +ST=15.5 %)

    EXHAUST
    FUEL GAS
    (100 %) TURBINE HEAT
    (67 %)

    MISC.
    (3.5 %)

    COMBINED CYCLE GAS TURBINE


    Energy Balance
    6 June 2018
    C:\UMESH\DEPT\GTDRG01.PPT....005 20
    Gas Turbine Technology - Features

    • Quick start and load changes Low Thermal Inertia

    • Low use of water Low heat evacuation

    • Black start facility Shaft driven auxiliaries

    • Facility of convenient layout Options for inlet/exhaust

    • Low impact on environment Low Emissions

    • Low installation time Packaging

    • Long inspection / replacement intervals Lower metal temperatures

    • Efficient topping machines High Exhaust Temperature

    • Compactness Compact subassemblies

    • Fuel Flexibility Combustion capability

    6 June 2018 21
    SWITCHYARD @ NTPC ANTA

    6 June 2018 PMI Revision 00 22


    VOLTAGE LEVEL IN SWITCHYARD – 220kV

    BUS BAR ARRANGEMENT – 2 MAIN + TRANSFER

    NO. OF BAYS IN SWITCHYARD – 12

    NO. OF OUT GOING FEEDERS - 6

    1. BHILWARA 1
    2. BHILWARA 2
    3. KOTA
    4. RAPP
    5. DAUSA
    6. LALSOT
    6 June 2018 23
    VOLTAGE LEVELS AT NTPC ANTA
    220kV- (GRID VOLTAGE)
    10.5kV – GAS TURBINE GENERATOR OUTPUT
    15.5kV – STG OUTPUT VOLTAGE
    6.6kV – BUS FOR HT DRIVES & FOR UAT’S
    1.37kV – STARTING POWER
    415V – LT DRIVES

    DC VOLTAGE LEVELS
    220V DC
    48V DC

    6 June 2018 PMI Revision 00 24


    AVAILABILITY BASED TARIFF SYSTEM
    TOTAL TIME BLOCK IN A DAY- 96 (15 MINUTE
    EACH)

    •CAPACITY CHARGES - AVAILABILITY OF


    GENERATING STATION

    •ENERGY CHARGES - ENERGY CHARGES FOR EX


    BUS GENERATION

    •UNSCHEDULED INTERCHANGE (UI) - CHARGES


    BASED ON AVERAGE FREQUENCY OF THE
    BLOCK

    6 June 2018 25
    THANK YOU

    6 June 2018 26

    You might also like