Pipeline Failure

PIPELINE FAILURE
Causes
Consequences
Fire and explosion
Gas dispersion
Spillage
Impact of failure Emergency response
Emergency response
Environmental impact Assessment
Environmental and risk management in construction
Decommissioning and Remediation
Causes
Wrongly specified design requirement which could lead to
Out of roundness
Fracture
Fatigue
Bursting
Collapse
Local buckling
Aging
Third party encroachment
Pipe wall damage by impact leading to Dents and gouges
Vandalism, sabotage, theft of pipeline product and terrorism,
Excavation damage - during installation of new piping system when where there is
an existing pipe
Seismic activity - earthquake, earth tremor etc
Water current, storm
Landslide
High wind
Overloading
Failure of relief system
Blockage e.g. hydrate plugs
Overpressure from pump overdrive
Poor installation
Bad welding
Weak coupling
Poor manufacturing Gasket failure
Low quality material
Not designing against major risks
Inherent Defects corrosion
Poor maintenance and management
Infrequent inspection and survey
Negligence
Fault Tree For Pipeline Rupture / Leakage
Consequences
1. Spillage
Danger to the public through explosion
Damage to environment ecosystem, water quality, land pollution, wild life and
vegetation, pollution of surface water, pollution of ground water, damage to
rare habitat e.g. (flora and fauna), damage to forest
2. Jet fires, crater fires, ball fires, heat, and fumes from leakages
3. Air pollution from fires
4. Sea pollution for subsea ruptures
5. Bad reputation
6. High cleanout costs
7. Loss of platform and subsea equipment
Causes of spillage - cold lines
Failure rate has not increased with age for lines up to 45 years old
Spills per year hot and cold lines

Data for liquid transmission pipelines in Europe to 2008.
Source Concawe
Comparison between hot and cold lines
Data for liquid transmission pipelines in Europe 1971 to 2008 Source Concawe
The main cause of failures for

oil and gas
transmission lines
Third party interference is the main cause of failures
4 times that of construction or materials defects

4 times that of corrosion
In 2007 avoidable 3rd party activities accounted for 34.6% of serious incidents, 36% of fatalities and $4.9m
of property damage (source OPS: USA)
Management of the pipeline right-of-way is a vital part of pipeline integrity management
Detection of 3rd party activities

Supervision of any work on or adjacent to the line
Carried out by land based, and/or aerial surveillance
o
o
Identification of deterioration; erosion, subsidence

Detection of small leaks, not otherwise detected
Education of Landowners
NOTABLE PIPELINE FAILURES
Failure due to corrosion of old

uninspectable line
Carlsbad New Mexico 19th August
2000
Natural gas explosion at a campsite
Pipeline was 50 yrs old
Crater 86ft x 46 ft x 20ft deep
12 members of one family died
Pipeline was not inspectable by
intelligent pigs due to dips and
turns
$2.5m fine on Operator
ailure due to accelerated internal corrosion

o 21st March 2006
o Leak from Trans-Alaska
pipeline
o At least 190000 litres of
oil released onto tundra
o Corrosion at a point
where line dips for
Caribou to cross,
o corrosion rate had unexpectedly accelerated
o Prudhoe Bay oilfield closed down on 9th
August 2006 losing 400000 barrels of oil/day
Production
o US$12 million federal criminal fine,
o US$4 million in criminal restitution to the

state
o US$4 million for Arctic research.
o BP Exploration (Alaska) Inc. on probation for
three years.
Failure due to external stress corrosion cracking

29th July 1995
Failure on a 42 inch grade X60
natural
gas pipeline approx 3 km southeast
of Rapid City Manitoba. (Pup was
X65)
9.6 m3 gas consumed by fire
The initial rupture occurred as a
result of a pre-existing stress
corrosion crack (SCC).
This piece of pipe had been
fabricated in the field and coated with
polyethylene tape.
Failure due to inadequate monitoring of adjacent works

Bellingham Washington State USA
10th June 1999 pipeline ruptured
Leaked 237000 gallons of gasoline into
Hannah and Whatcom Creeks
Vapour cloud ignited at Whatcom Creek
Two 10 year old boys and an 18 year

old died
$45m losses
NTSB stated
damaged during construction of the water

plant in 1994 5 years previously
inadequate supervision of this work
Pipeline operator has misinterpreted inline
inspection data and failed to repair
inadequacies in the safety devices
Initial fine of 3.05m on Operator $7.8m

fine on companies involved
Four employees indicted for
violations of pipeline safety act
ailure due to accidental third party damage

Ghislenghien, near Ath, Belgium 30th July 2004
Natural gas pipeline from Zeebrugge to France
Major gas leak detected and emergency services called. when emergency
services arrived there was an explosion.
Service station blown up, factory destroyed. Cars blown 500m, total
destruction
zone of 400m radius. Debris found 6km away. Factors:
Construction work had progressed around the pipeline

A new roadway had been constructed over the line
A 10mm deep notch on the pipe surface initiated the failure
There was also the possibility of damage being from earlier agricultural
machinery
Theft/Bunkering in Nigeria [BBC,

26/12/06]
o
o
o
o
o
o
o
o
December 2006: >260 killed in Lagos

May 2006: >150 killed in Lagos
December 2004: >20 killed in Lagos
September 2004: >60 killed in Lagos
June 2003: >105 killed in Abia State
July 2000: >300 killed in Warri
March 2000: >50 killed in Abia State
October 1998: >1,000 killed in Jesse
Ghislenghien,Belgium 30 July 2004

th
Risks to an operator
Loss of production
Cost of remedial work

Cost of incident management
Legal action
Damage to reputation and public image
Increasing external regulation which may be excessive or
inappropriate
What the Operator needs to avoid the risks

o Asset availability to assure revenue and a financial return
oCompliance with regulatory requirements
oAssured system integrity
Pipeline integrity and operability

Public and personnel protection
Protection of the environment
Methods of pipeline monitoring

1
2
3
4
5
Routine surveys
Cathodic protection
System based monitoring
Corrosion monitoring
Pigging and intelligent pigging
Methods currently being adopted by other countries

to counter theft from pipeline through illegal Tapping
Install CCTVs
Barriers
Motion detectors
Online leak detection systems
Aerial surveillance
Fiver optic cables used to detect defects (can be easy target for
vandalism)
Impact monitors that pick up vibrations
Partner with stakeholders particularly local communities
Educate the local communities about the benefits of the pipelines
FIRE AND EXPLOSION

Pipeline Failure

Uploaded by

Copyright:

Available Formats

Pipeline Failure

Uploaded by

Document Information

Original Description:

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Pipeline Failure

Uploaded by

Copyright:

Available Formats

What are some of the main causes of pipeline failures?

What are some of the main causes of pipeline failures?

What are some of the consequences of pipeline failures?

What are some of the consequences of pipeline failures?

PIPELINE FAILURE

Fault Tree For Pipeline Rupture / Leakage

Causes of spillage - cold lines

Spills per year hot and cold lines

Comparison between hot and cold lines

The main cause of failures for

4 times that of construction or materials defects

Management of the pipeline right-of-way is a vital part of pipeline integrity management

Detection of 3rd party activities

Identification of deterioration; erosion, subsidence

NOTABLE PIPELINE FAILURES

Failure due to corrosion of old

ailure due to accelerated internal corrosion

o US$4 million in criminal restitution to the

Failure due to external stress corrosion cracking

Failure due to inadequate monitoring of adjacent works

Two 10 year old boys and an 18 year

damaged during construction of the water

Initial fine of 3.05m on Operator $7.8m

ailure due to accidental third party damage

Construction work had progressed around the pipeline

Theft/Bunkering in Nigeria [BBC,

December 2006: >260 killed in Lagos

Ghislenghien,Belgium 30 July 2004

Cost of remedial work

What the Operator needs to avoid the risks

Pipeline integrity and operability

Methods of pipeline monitoring

Methods currently being adopted by other countries

FIRE AND EXPLOSION

You might also like