2006 Scion Engine Manual

SCION
1
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
2006
2
32839
3
32849
Vehicle Identification Model Body code Year Engine No. of cylinders/Type Capacity Output Ignition system Fuel system
32963
tC 2.4L 2005-06
Code (VIN) 2AZ-FE (VIN 5 = D/E) cm3 hp/rpm Description Trigger location Make Type Description Type
xA 1.5L 2003-06 1NZ-FE (VIN 5 = T) 4/DOHC 1497 108/6000 Mapped-DIS Camshaft, crankshaft Toyota TCCS Multi-port, sequential Mass meter
xB 1.5L 2004-06 1NZ-FE (VIN 5 = T) 4/DOHC 1496 108/6000 Mapped-DIS Camshaft, crankshaft Toyota TCCS Multi-port, sequential Mass meter 1-3-4-2 8-12/650 N=Not adjustable 65050 Not adjustable AT=70050 Not adjustable Denso K16R-U 0.7-0.8 0.15-0.25 cold 0.25-0.35 cold 14.6 1.5-5.5/3000 5W/30 Semi-Synth. 5W/30 Semi-Synth. 10W/30 Semi-Synth. SL 3.9 75W/90 2.0 T-IV 3.1 75W/90 2.0 4.7 AT=4.5 DOT 3 Dexron II/III 0.7 20 mm 0.5 mm/ 201 mm 1 mm/ 1 mm
Air metering
Tuning Firing order 18 Ignition timing BTDC aEngine/rpm 19 o without + with vacuum 20 Idle speed (curb) rpm 21 alternative (curb) rpm 22 Service checks and adjustments 23 O E Spark plugs Make 24 Type 25 Electrode gap mm 26 Valve lash - intake mm 27 - exhaust mm 28 Compression pressure bar 29 Oil pressure bar/rpm 30 Lubricants and capacities 31 Engine oil grade - cold climate SAE 32 - moderate climate SAE 33 - hot climate SAE 34 Engine oil classification API 35 Engine with filter quarts 36 Gearbox oil grade SAE 37 4/5/6 speed quarts 38 Automatic transmission fluid Type 39 drain and refill quarts 40 Transfer case SAE 41 drain and refill quarts 42 Front differential oil grade SAE 43 drain and refill quarts 44 Rear differential oil grade SAE 45 drain and refill quarts 46 Cooling system quarts 47 Brake fluid Type 48 system quantity quarts 49 Power steering fluid Type 50 system quantity quarts 51 Brake dimensions 52 Minimum rotor thickness - solid front 53 - ventilated front 54 Minimum rotor thickness rear 55 Thickness variation front/rear 56 Rotor runout front/rear 57 Maximum drum diameter rear 58 Minimum pad thickness front/rear 59 Minimum shoe thickness rear
637 &
4/DOHC 2362 160/5700 Mapped-DI Camshaft, crankshaft Toyota TCCS Multi-port, sequential Mass meter
1-3-4-2 1-3-4-2 5-15/700 Not adjustable 8-12/650 Not adjustable 70050 Not adjustable 65050 Not adjustable 1244 AT=66050 Not adjustable &Not adjustable Denso SK20R11 1.0-1.1 0.19-0.29 cold 0.30-0.40 cold 13.0 2.5-5.4/3000 5W/30 Semi-Synth. 5W/30 Semi-Synth. 5W/30 Semi-Synth. SL 4.0 75W/90 2.6 T-IV 3.7 7.2 AT=7.1 DOT 3 Dexron II/III 23 mm 7.5 mm 0.05 mm/0.15 mm 174 mm 1 mm/1 mm 1 mm Denso K16R-U 0.7-0.8 0.15-0.25 cold 0.25-0.35 cold 14.6 1.5-5.5/3000 5W/30 Semi-Synth. 5W/30 Semi-Synth. 10W/30 Semi-Synth. SL 3.9 75W/90 2.0 T-IV 3.1 75W/90 2.0 4.7 AT=4.5 DOT 3 Dexron II/III 0.7 20 mm 0.5 mm/ 201 mm 1 mm/ 1 mm
438
& = refer to Tuning Conditions and Notes at the end of this manual
2006
1
60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109
SCION
2
32839
3
32849
Tightening torques Cylinder head Renew bolts Maximum bolt length Torque Torque Loosen Individually loosen ft. lbs. = foot pounds ins. lbs. = inch pounds Torque o = angular torque Run engine f= proceed to next stage Wait Nm conversion, Individually loosen see last page Torque Run engine Wait Individually loosen Torque Torque Tightening sequence - see illustrations below Main bearings Renew bolts/nuts Stage 1 Stage 2 Big end bearings Renew bolts/nuts Stage 1 Stage 2 Oil pump to cylinder block Oil pan bolts Oil pan drain bolt Drive plate Torque converter Flywheel Clutch cover to flywheel Crankshaft pulley/damper center bolt Camshaft sprocket/gear Camshaft carrier/cap Camshaft/valve cover Intake manifold to cylinder head Exhaust manifold to cylinder head Spark plugs Crankshaft position sensor Oxygen sensor (Lambda) Knock sensor Front hub Rear hub Steering track rod end Brake caliper to carrier front Brake caliper carrier to hub front Brake caliper to carrier rear Brake caliper carrier to hub rear ABS sensor front/rear Road wheels
32963
1431 &
164.2 mm 29 ft. lbs. 58 ft. lbs. f f 90a 75925
1241 &
147.1 mm 22 ft. lbs. 90a f f 90a 75950
1241 &
147.1 mm 22 ft. lbs. 90a f f 90a 75950 16 ft. lbs.+90a
629 &
1)15 ft. lbs. 2)30 ft. lbs. 16 ft. lbs.+90a 3)90a

1240 &
1240 &
657 &
9 ft. lbs. 2)18 ft. lbs. 3)90a 14 ft. lbs. 7 ft. lbs. 30 ft. lbs. 72 ft. lbs. 30 ft. lbs. 96 ft. lbs. 14 ft. lbs. 133 ft. lbs. 40 ft. lbs.
1433 &
8 ft. lbs. 22 ft. lbs. 27 ft. lbs. 7 ft. lbs. 32 ft. lbs. 15 ft. lbs. 159 ft. lbs. 103 ft. lbs. 36 ft. lbs. 25 ft. lbs. 79 ft. lbs.
1245 &
11 ft. lbs.+90a 28 ft. lbs. 20 ft. lbs. 36 ft. lbs.+90a 14 ft. lbs. 95 ft. lbs. 47 ft. lbs. 1239 36 ft. lbs. & 7 ft. lbs. 22 ft. lbs. 20 ft. lbs. 6 ft. lbs. 32 ft. lbs. 32 ft. lbs. 159 ft. lbs. 159 ft. lbs.
1239 &
11 ft. lbs.+90a 28 ft. lbs. 20 ft. lbs. 36 ft. lbs.+90a 14 ft. lbs. 95 ft. lbs. 47 ft. lbs.
34 ft. lbs. 6 ft. lbs./ 76 ft. lbs.
25 ft .lbs. 65 ft. lbs. 6 ft. lbs./ 76 ft. lbs. 75950
7 ft. lbs. 22 ft. lbs. 20 ft. lbs. 6 ft. lbs. 32 ft. lbs. 32 ft. lbs. 159 ft. lbs. 159 ft. lbs. 36 ft. lbs. 25 ft .lbs. 65 ft. lbs. 6 ft. lbs./ 76 ft. lbs.
75925
10
AD75925
7 10 6 1 3 7
AD75950
Refer to last page of this manual for Conversion Tables
439

2006 Scion Engine Manual

Uploaded by

Copyright:

Available Formats

2006 Scion Engine Manual

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

2006 Scion Engine Manual

Uploaded by

Copyright:

Available Formats

SCION

164.2 mm 29 ft. lbs. 58 ft. lbs. f f 90a 75925

147.1 mm 22 ft. lbs. 90a f f 90a 75950

147.1 mm 22 ft. lbs. 90a f f 90a 75950 16 ft. lbs.+90a

1)15 ft. lbs. 2)30 ft. lbs. 16 ft. lbs.+90a 3)90a

34 ft. lbs. 6 ft. lbs./ 76 ft. lbs.

25 ft .lbs. 65 ft. lbs. 6 ft. lbs./ 76 ft. lbs. 75950

Refer to last page of this manual for Conversion Tables

You might also like