// Detailed_Emissions_Solutions.

json
{
"metadata": {
"timestamp": "2025-04-19 10:04:00",
"author": "ecumaster1",
"version": "4.0.0"
},
"DPF_complete_solution": {
"identification": {
"pressure_sensor_maps": {
"primary": {
"pattern": "44 50 46 5F 50 52 53 5F 31",
"offset": "0x25000",
"size": "32 bytes",
"solution": {
"method": "Zero values",
"write": "00 00 00 00 00 00 00 00",
"verification": "Check all bytes zeroed"
}
},
"secondary": {
"pattern": "44 50 46 5F 50 52 53 5F 32",
"offset": "0x25100",
"solution": {
"method": "Fixed value simulation",
"value": "0.1 bar differential"
}
}
},
"temperature_sensors": {
"pre_dpf": {
"pattern": "44 50 46 5F 54 31",
"offset": "0x25200",
"solution": {
"method": "Fixed temperature",
"value": "300°C normal operation",
"write_value": "FF FF FF FF"
}
},
"post_dpf": {
"pattern": "44 50 46 5F 54 32",
"offset": "0x25300",
"solution": {
"method": "Fixed temperature",
"value": "280°C normal operation"
}
}
},
"regeneration_control": {
"main_trigger": {
"pattern": "44 50 46 5F 52 47 4E 5F 54 52 47",
"offset": "0x26000",
"solution": {
"method": "Disable completely",
"write": "00 00 00 00"
}
},
"post_injection": {
 "pattern": "50 53 54 5F 49 4E 4A",
"offset": "0x26100",
"solution": {
"method": "Remove post injection",
"maps": [
"Quantity map",
"Timing map",
"Enable conditions"
]
}
},
"soot_mass": {
"pattern": "53 4F 4F 54 5F 4D 41 53",
"offset": "0x26200",
"solution": {
"method": "Fixed low value",
"value": "2g permanent"
}
}
}
}
},
"EGR_complete_solution": {
"valve_control": {
"primary_control": {
"pattern": "45 47 52 5F 43 54 4C 5F 31",
"offset": "0x27000",
"solution": {
"method": "Force closed position",
"write": "00 00",
"verification": "Position sensor reads closed"
}
},
"flow_maps": {
"main_map": {
"pattern": "45 47 52 5F 46 4C 57 5F 4D",
"offset": "0x27100",
"size": "16x16",
"solution": {
"method": "Zero flow matrix",
"additional": "Optimize timing maps"
}
},
"cold_start": {
"pattern": "45 47 52 5F 43 4C 44",
"offset": "0x27200",
"solution": {
"method": "Disable cold start EGR",
"compensation": "Adjust fuel quantity"
}
}
},
"temperature_control": {
"pattern": "45 47 52 5F 54 45 4D 50",
"offset": "0x27300",
"solution": {
"method": "Fixed normal temperature",
"value": "90°C simulation"
}
 }
}
},
"SCR_complete_solution": {
"nox_sensors": {
"upstream": {
"pattern": "4E 4F 58 5F 55 50",
"offset": "0x28000",
"solution": {
"method": "Fixed values simulation",
"idle": "200ppm",
"cruise": "150ppm",
"full_load": "300ppm"
}
},
"downstream": {
"pattern": "4E 4F 58 5F 44 4F 57 4E",
"offset": "0x28100",
"solution": {
"method": "Fixed ratio calculation",
"value": "80% reduction simulation"
}
}
},
"urea_injection": {
"dosing_control": {
"pattern": "55 52 45 41 5F 44 4F 53",
"offset": "0x28200",
"solution": {
"method": "Disable injection",
"maps": [
"Base dosing",
"Temperature correction",
"Load correction"
]
}
},
"level_sensor": {
"pattern": "55 52 45 41 5F 4C 56 4C",
"offset": "0x28300",
"solution": {
"method": "Fixed level simulation",
"value": "75% permanent"
}
}
}
},
"optimization_after_removal": {
"fuel_maps": {
"main_quantity": {
"pattern": "46 55 45 4C 5F 4D 41 49 4E",
"offset": "0x29000",
"adjustments": {
"low_load": "Optimize without EGR influence",
"high_load": "Remove DPF restrictions"
}
},
"injection_timing": {
"pattern": "49 4E 4A 5F 54 49 4D",
 "offset": "0x29100",
"adjustments": {
"advance": "1-2° throughout map",
"reason": "Better combustion without EGR"
}
}
},
"boost_control": {
"target_map": {
"pattern": "42 53 54 5F 54 47 54",
"offset": "0x29200",
"adjustments": {
"low_end": "Increase 0.2bar",
"mid_range": "Optimize for no back pressure",
"high_end": "Remove DPF limitations"
}
}
}
},
"verification_steps": {
"initial_checks": [
"No pressure differential",
"Normal temperature readings",
"No regeneration requests",
"EGR valve closed",
"No SCR dosing"
],
"running_checks": {
"cold_start": "Check smooth operation",
"idle": "Verify stable",
"acceleration": "Monitor smoke",
"cruise": "Check fuel economy",
"full_load": "Monitor EGTs"
},
"diagnostic_verification": {
"no_dtc_set": [
"P2002 - DPF",
"P0401 - EGR",
"P20EE - SCR"
],
"sensors_reading": "All within normal ranges"
}
}
}