VAUXHALL/OPEL Corsa-B & Combo 1.
4 MPI
1993 to 1994
Engine & Running Torque Notes &
Fuel Ignition Electrical Capacities
Cooling gear settings Illustrations
VAUP1101404
Automotive
Technical
DATA Click on one of the
buttons above to view
data for this car. To
BOOK return to this screen and
make another choice,
click anywhere on the
data screen.
MENU HELP
Engine and cooling system Corsa-B & Combo 1.4 MPI 1993 to 1994
Type C14SE SOHC. 60kW 91/441/EEC
Capacity (cm3) / number of cylinders 1389 / 4
Compression ratio / pressure bar 9.8 / _
Oil pressure bar 1.5
Oil temperature ºC ≥80
Valve clearance - inlet mm 0: Hyd.
Valve clearance - exhaust mm 0: Hyd.
Firing order 1-3-4-2
No 1 cylinder position TBE
Thermostat opening temperature ºC 88 to 106
Radiator cap pressure bar 1.2 to 1.4
Fuel system Corsa-B & Combo 1.4 MPI 1993 to 1994
Idle speed - manual [auto] rpm 850 to 1010 N/A
Fast idle speed - manual [auto] rpm _
CO @ idle speed [3000 rpm] - see page VI % 1.5±0.5 WSM
HC @ idle speed [3000 rpm] - see page VI ppm ≤200
CO2 @ idle speed [3000 rpm] - see page VI % _
O2 @ idle speed [3000 rpm] - see page VI % _
Carburettor / fuel injection GM
Type / ref Multec-M
Main jet / needle _
Injection pressure bar 3.0
Pump pressure bar _
Octane rating RON 95[U]
Ignition system Corsa-B & Combo 1.4 MPI 1993 to 1994
Type Multec-DIS
Ignition coil Dual spark
Primary resistance ohms 0.56±0.05
Ballast resistor ohms _
Voltage - Tmnl 15(+) to earth V _
Distributor _
Points gap (air gap) mm _
Dwell angle º (%) Electronic control
Condenser capacity µF _
Rotation Anticlockwise
Ignition timing - basic [static º Crankshaft @ rpm 5 BTDC @ 850 to 1010 N/A
V = Vacuum NV = No Vacuum NV
Total ignition advance º Crankshaft @ rpm _
º Crankshaft @ rpm _
º Crankshaft @ rpm _
Centrifugal check. º Crankshaft @ rpm Computer control
º Crankshaft @ rpm _
º Crankshaft @ rpm _
Vacuum range check mbar Computer control
Maximum vacuum advance º Crankshaft _
Spark plugs Bosch/Champion
Type WR7DC / RN7YC
Electrode gap mm 0.70 to 0.80
Electrical system Corsa-B & Combo 1.4 MPI 1993 to 1994
Battery V / CC / RC 12 / 180 / 36Ah or / 210 / 44
Alternator voltage / full load current / engine rpm 14.7±0.5 / 55, 70 / 3500
Starter motor current / voltage - cranking A/V 70 / 11.5 (no load)
Starter motor current / voltage - locked A/V 450 to 650 / 5.6
Running gear Corsa-B & Combo 1.4 MPI 1993 to 1994
Brakes -
Front (min. friction material thickness) mm 7.0 with backing
Rear (min. friction material thickness) mm 0.5 above rivets
Tyres
Saloon Size 145x13: 165/70x13: 165/65x14
Estate / Van Size 165/70x13
Pressure - front / rear - Saloon bar 2.1 / 1.91
Pressure - front / rear - Estate / Van bar 1.9 / 1.9
Front suspension / wheel alignment
Toe-in (+) / Toe-out (–) mm [º] +0.5±1.0 L
Camber -35’±45’ L
Castor +1°50’±1° L
King pin inclination _
Rear suspension / wheel alignment
Toe-in (+) / Toe-out (–) mm [º] +1.0+3.0-1.5
Camber -1°30’±30’ L
Torque wrench settings Corsa-B & Combo 1.4 MPI 1993 to 1994
Cylinder head - stage 1 Nm 25 N
Cylinder head - stage 2 Nm + 60°
Cylinder head - stage 3 Nm + 60°
Cylinder head - stage 4 Nm + 60°
Big-end bearings Nm 252
Main bearings Nm 50 +45° +15° N
Clutch cover Nm 15
Flywheel [driveplate] Nm 35 +30° +15° N
Front hubs Nm WSM
Rear hubs Nm WSM
Wheel nuts / bolts Nm 110
Spark plugs Nm 25
Capacities Corsa-B & Combo 1.4 MPI 1993 to 1994
Engine oil & filter litres 3.5
Gearbox - 4-speed [5-speed] litres 1.6
Automatic transmission - refill litres _
Final drive litres WT
Cooling system litres 5.8. A/c: 6.1
Fuel tank litres 46. Combo: 50
Notes and Illustrations
With A/c: 2.2 / 2.0
1
40mm bolt: 25 +30° N
2
1389 cm3, 8V
