DV-610AV Service Manual

ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan

PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2008
2008 Printed in Japan
OPEN/CLOSE
HDMI
HOME MENU RETURN
ENTER
TOP MENU MENU
USB DVD/USB
STANDBY/ON
2 5 3 6 7 1
9 8 12 13
DV-610AV-S
RRV3798
DVD PLAYER
DV-610AV-S
DV-610AV-K
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model Type Power Requirement Region No. Remarks
DV-610AV-S WYXZT5 AC 220 V to 240 V 2
DV-610AV-S WVXZT5 AC 220 V to 240 V 2
DV-610AV-S WSXZT5 AC 220 V to 240 V 5
DV-610AV-K WYXZT5 AC 220 V to 240 V 2
DV-610AV-K WSXZT5 AC 220 V to 240 V 5
For details, refer to "Important Check Points for good servicing".
T-ZZV JUNE
2 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
SAFETY INFORMATION
This service manual is intended for qualified service technicians ; it is not meant for the casual
do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been
trainedto properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely,
you should not risk trying to do so and refer the repair to a qualified service technician.
WARNING !
THE AEL (ACCESSIBLE EMISSION LEVEL) OF THE LASER POWER OUTPUT IS LESS THAN CLASS 1
BUT THE LASER COMPONENT IS CAPABLE OF EMITTING RADIATION EXCEEDING THE LIMIT FOR
CLASS 1.
A SPECIALLY INSTRUCTED PERSON SHOULD DO SERVICING OPERATION OF THE APPARATUS.
LASER DIODE CHARACTERISTICS
FOR DVD : MAXIMUM OUTPUT POWER : 5 mW
WAVELENGTH : 650 nm
FOR CD : MAXIMUM OUTPUT POWER : 5 mW
WAVELENGTH : 780 nm
Additional Laser Caution
: See page 27.
1.
Laser diode is driving with Q2303,Q2305(650 nm LD) and Q2302,
Q2304(780 nm LD)on the DVD MT PCB Assy.
Therefore, when short-circuit between the emitter and collector of these
transistors or the base voltage is supplied for transistors turn on, the
laser oscillates. (failure mode)
In the test mode , there is the mode that the laser oscillates except
for the disc judgment and playback. LD ON mode in the test mode
oscillates with the laser forcibly.

2. When the cover is open, close viewing through the objective lens with
the naked eye will cause exposure to the laser beam.
LABEL CHECK
(Printed on the Rear Panel)
Location: inside of the unit
OPEN/CLOSE
HDMI
HOME MENU
RETURN
ENTER
TOP MENU
MENU
USB
DVD/USB
STANDBY/ON
3 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
4 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
CONTENTS
SAFETY INFORMATION..........................................................................................................................................................2
1. SERVICE PRECAUTIONS....................................................................................................................................................5
1.1 NOTES ON SOLDERING...............................................................................................................................................5
1.2 WHEN REPLACING DVD DECK....................................................................................................................................5
1.3 DISC REMOVAL METHOD.............................................................................................................................................6
2. SPECIFICATIONS.................................................................................................................................................................7
2.1 ACCESSORIES..............................................................................................................................................................7
2.2 SPECIFICATIONS...........................................................................................................................................................8
2.3 DISC/CONTENT FORMAT .............................................................................................................................................9
2.4 PANEL FACILITILES.....................................................................................................................................................11
3. BASIC ITEMS FOR SERVICE.............................................................................................................................................13
3.1 CHECK POINTS AFTER SERVICING..........................................................................................................................13
3.2 PCB LOCATIONS .........................................................................................................................................................14
3.3 JIGS LIST .....................................................................................................................................................................15
4. BLOCK DIAGRAM...............................................................................................................................................................16
4.1 OVERALL WIRING DIAGRAM......................................................................................................................................16
4.2 OVERALL BLOCK DIAGRAM.......................................................................................................................................18
4.3 DVD LOADER/MPEG BLOCK DIAGRAM.....................................................................................................................19
4.4 POWER BLOCK DIAGRAM..........................................................................................................................................20
5. DIAGNOSIS.........................................................................................................................................................................21
5.1 TROUBLE SHOOTING.................................................................................................................................................21
5.2 METHOD FOR DIAGNOSING DEGRADATION OF THE LDS ON THE PICKUP ASSY .............................................26
6. SERVICE MODE.................................................................................................................................................................27
6.1 SERVICE MODE PROCEDURE...................................................................................................................................27
6.2 SERVICE MODE IN......................................................................................................................................................28
6.3 DISPLAY SPECIFICATION OF THE SERVICE MODE ................................................................................................29
6.4 FUNCTIONAL SPECIFICATION OF THE SHORTCUT KEY........................................................................................30
6.5 FUNCTIONAL SPECIFICATION OF THE SERVICE MODE ........................................................................................31
7. DISASSEMBLY....................................................................................................................................................................32
8. EACH SETTING AND ADJUSTMENT ................................................................................................................................37
8.1 RE-WRITE FOR DVD FIRMWAVE ...............................................................................................................................37
9. EXPLODED VIEWS AND PARTS LIST...............................................................................................................................40
9.1 PACKING ......................................................................................................................................................................40
9.2 EXTERIOR SECTION...................................................................................................................................................42
9.3 06 DVD MECHA SECTION...........................................................................................................................................44
10. SCHEMATIC DIAGRAM....................................................................................................................................................46
10.1 DVD MT PCB ASSY(1/7) ............................................................................................................................................46
10.2 DVD MT PCB ASSY(2/7) ............................................................................................................................................48
10.3 DVD MT PCB ASSY(3/7) ............................................................................................................................................50
10.4 DVD MT PCB ASSY(4/7) ............................................................................................................................................52
10.5 DVD MT PCB ASSY(5/7) ............................................................................................................................................54
10.6 DVD MT PCB ASSY(6/7) ............................................................................................................................................56
10.7 DVD MT PCB ASSY(7/7) ............................................................................................................................................58
10.8 OPERATION PCB ASSY ............................................................................................................................................60
10.9 POWER PCB ASSY(1/2) ............................................................................................................................................62
10.10 POWER PCB ASSY(2/2) ..........................................................................................................................................64
10.11 WAVEFORMS...........................................................................................................................................................66
11. PCB CONNECTION DIAGRAM........................................................................................................................................68
11.2 DVD MT PCB ASSY....................................................................................................................................................69
11.3 OPERATION PCB ASSY ............................................................................................................................................71
11.4 POWER PCB ASSY....................................................................................................................................................72
11.1 LOADING MOTOR and SW........................................................................................................................................68
12. PCB PARTS LIST..............................................................................................................................................................74
5 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
1. SERVICE PRECAUTIONS
1.1 NOTES ON SOLDERING
1.2 WHEN REPLACING DVD DECK
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Do NOT use a soldering iron whose tip temperature cannot be controlled.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
The following lead-free solders are available as service parts:
Parts numbers of lead-free solder:
GYP1006 1.0 in dia.
GYP1007 0.6 in dia.
GYP1008 0.3 in dia.
Before removing Pick Up PCB and DVD PCB connector, short circuit the position shown in Fig. 1 using
a soldering iron. If you remove the DVD Deck with no soldering, the Laser may be damaged.
WHEN REPLACING DVD DECK
[ Removing the DVD Deck ]
[ Installing the DVD Deck ]
Remove all the soldering on the short circuit position after the connection of Pick Up PCB and DVD
PCB connector.
NOTE
Fig. 1
Before your operation, please read PREPARATION OF SERVICING .
Use the Lead Free solder.
Manual soldering conditions
Soldering temperature: 320 20 C
Soldering time: Within 3 seconds
Soldering combination: Sn-3.0Ag-0.5Cu
When Soldering/Removing of solder, use the draw in equipment over the Pick Up Unit to prevent the
Flux smoke from it.
Short circuit using a

soldering iron.
Pick Up PCB
6 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
1.3 DISC REMOVAL METHOD
The laser diode used for a pickup head may be destroyed with external static electricity.
Moreover, even if it is operating normally after repair, when static electricity discharge is
received at the time of repair, the life of the product may be shortened.
Please perform the following measure against static electricity, be careful of destruction of a
laser diode at the time of repair.
Place the unit on a workstation equipped to protect against static electricity, such as
conductive mat.
Soldering iron with ground wire or ceramic type is used.
A worker needs to use a ground conductive wrist strap for body.
PREPARATION OF SERVICING
If the stored 4 digit password in the Rating Level menu needs to be cancelled, please follow the steps
below.
Set the DVD to the Stand-by Mode.
Press and hold the 'STOP' key on the front panel.
Simultaneously press and hold the POWER key on the front panel.
The 4 digit password has now been cleared.
1.
2.
3.
4.
PARENTAL CONTROL - RATING LEVEL
4 DIGIT PASSWORD CANCELLATION
NOTE: The above procedure will reset ALL of the player's settings to the default factory state.
Slide the Rack Loading (White) toward the arrow direction by using a minus driver to release the lock.
(Refer to Fig. 1)
Manually open the Tray.
Please strongly pushing Rack Loading (White) to release the lock because the tray doesn't go out
easily.
1.
2.
Fig. 1
Rack Loading (White)
DVD Player (Bottom Side)
NOTE:
DISC REMOVAL METHOD AT NO POWER SUPPLY
7 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
2. SPECIFICATIONS
2.1 ACCESSORIES
Accessories
Remote control x1
(076E0PP121:DV-610AV-S)
(076E0PP131:DV-610AV-K)
Power cable x1
(1206158802 : WYXZT5, WSXZT5)
Audio / Video cable(1.2m) x1
(red/white/yellow)
(06CPBA2006)
Dry cell batteries x2
(AA/R6P)
Warranty Card
Operating Instructions
(1206138802 : WVXZT5)
8 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
2.2 SPECIFICATIONS
General
Power requirements. . . . AC 220 V to 240 V, 50 Hz/60 Hz
Power consumption. . . . . . . . . . . . . . . . . . . . . . . . . .12 W
Power consumption (standby) . . . . . . . . . . . . . . . . 0.8 W
Weight. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.7 kg
Dimensions
. . . . . . . . . . . 420 mm (W) x 49.5 mm (H) x 215.5 mm (D)
Operating temperature . . . . . . . . . . . . . .+5 C to +35 C
Operating humidity . . . . 5 % to 85 % (no condensation)
AV Connector
(21-pin connector assignment)
AV connector output . . . . . . . . . . . . . . .21-pin connector
This connector provides the video and audio signals for
connection to a compatible colour TV or monitor.
PIN no.
1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Audio 2/R out
3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Audio 1/L out
4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GND
7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .B out
8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Status
11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .G out
15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .R out
17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GND
19. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Video out
21. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GND
Component video output
Y (luminance) - Output level . . . . . . . . . . . . 1 Vp-p (75 )
P
B
(color) - Output level. . . . . . . . . . . . . . .0.7 Vp-p (75 )
P
R
(color) - Output level. . . . . . . . . . . . . . .0.7 Vp-p (75 )
Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RCA
S-video output
Y (luminance) - Output level . . . . . . . . . . . . 1 Vp-p (75 )
C (color) - Output level. . . . . . . . . . . . . .286 mVp-p (75 )
Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . S-video
Video output
Output level . . . . . . . . . . . . . . . . . . . . . . . . . 1 Vp-p (75 )
Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RCA
Audio output (1 stereo pair)
Output level. . . . . . . . . . . . . . . . . . . .During audio output
200 mVrms (1 kHz, 20 dB)
Number of channels. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Jacks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RCA
Audio output (multi-channel / L, R, C, SW,
SL, SR)
Output level. . . . . . . . . . . . . . . . . . . .During audio output
200 mVrms (1 kHz, 20 dB)
Number of channels . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Jacks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RCA
HDMI output
HDMI output. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19pin
Digital audio characteristics
Frequency response. . . . . . . . . . . . . . . . . . 4 Hz to 44 kHz
S/N ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 115 dB
Dynamic range . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100 dB
Total harmonic distortion. . . . . . . . . . . . . . . . . . .0.0023 %
Wow and flutter . . . . . . . . . . . . . . Limit of measurement
(0.001 %W. PEAK) or lower
Digital outputs
Coaxial digital output. . . . . . . . . . . . . . . . . . . . . . . . . RCA
Optical digital output . . . . . . . . . . . . . . . . . . . . . . . Optical
Accessories
Remote control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
AA/R6P dry cell batteries. . . . . . . . . . . . . . . . . . . . . . . . 2
Audio/video cable. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Power cable. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Warranty card. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Operating instructions
The specifications and design of this product are subject
to change without notice, due to improvement.
Published by Pioneer Corporation.
Copyright 2008 Pioneer Corporation.
All rights reserved.
9 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
2.3 DISC/CONTENT FORMAT
Disc/content format playback compatibility
This player is compatible with a wide range of disc types (media) and
formats. Playable discs will generally feature one of the following
logos on the disc and/or disc packaging. Note however that some
disc types, such as recordable CD and DVD, may be in an
unplayable formatsee below for further compatibility information.
Please also note that recordable discs cannot be recorded
using this player.
This unit will play DVD+R/+RW discs.
is a trademark of DVD Format/Logo Licensing
Corporation.
is a trademark of FUJIFILM Corporation.
Also compatible with KODAK Picture CD
This player supports the IECs SuperVCD standard. Compared to
the VideoCD standard, SuperVCD offers superior picture quality,
and allows two stereo soundtracks to be recorded. SuperVCD also
supports the widescreen size.
About DualDisc playback
A DualDisc is a new two -sided disc, one side of which contains DVD
content video, audio, etc. while the other side contains non-DVD
content such as digital audio material.
The non-DVD, audio side of the disc is not compliant with the CD
audio specification and therefore may not play.
The DVD side of a DualDisc plays in this product.
For more detailed information on the DualDisc specification, please
refer to the disc manufacturer or disc retailer.
CD-R/-RW compatibility
Compatible formats: CD-audio, Video CD/Super VCD, ISO 9660
CD-ROM* containing MP3, WMA, MPEG-4 AAC, JPEG or DivX
video/WMV files
*ISO 9660 Level 1 or 2 compliant. CD physical format: Mode1,
Mode2 XA Form1. Romeo and Joliet file systems are both
compatible with this player.
Multi-session playback: No
Unfinalized disc playback: No
File structure (may differ): Up to299 folders on a disc;
up to 648 folders and files (combined) within each folder
DVD+R/+RW compatibility
Only DVD+R/DVD+RW discs recorded in Video Mode (DVD Video
Mode) which have been finalized, can be played back. However,
some editing made during the recording may not be played back
accurately.
DVD-R/-RW compatibility
Compatible formats: DVD-Video, Video Recording (VR)*
* Edit points may not play exactly as edited; screen may go
momentarily blank at edited points.
Unfinalized playback: No
MP3/WMA/MPEG-4 AAC/JPEG or DivX video/WMV file playback
on DVD-R/-RW: Yes
Compressed audio compatibility
Compatible formats: MPEG-1 Audio Layer 3 (MP3), Windows
Media Audio (WMA), MPEG-4 AAC
Sampling rates: 32 kHz, 44.1 kHz or 48 kHz
Bit-rates: Any (128 kbps or higher recommended)
VBR (variable bit rate) MP3/WMA/MPEG-4 AAC playback: No
WMA lossless encoding compatible: No
DRM (Digital Rights Management) compatible: No (DRM-
protected audio files will not play in this player
File extensions: .mp3, .wma, .m4a (these must be used for the
player to recognize MP3, WMA and MPEG-4 AAC filesdo not
use for other file types)
Super VCD
10 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
About MPEG-4 AAC
Advanced Audio Coding (AAC) is at the core of the MPEG-4 AAC
standard, which incorporates MPEG-2 AAC, forming the basis of the
MPEG-4 audio compression technology. The file format and
extension used depend on the application used to encode the AAC
file. This unit plays back AAC files encoded by iTunes
bearing the
extension .m4a. DRM-protected files will not play, and files
encoded with some versions of iTunes
may not play, or filenames

may display incorrectly.
Apple and iTunes
are trademarks of Apple Inc., registered in the

U.S. and other countries.
WMA (Windows Media Audio) compatibility
This player can playback Windows Media Audio content.
WMA is an acronym for Windows Media Audio and refers to an
audio compression technology developed by Microsoft Corporation.
WMA content can be encoded by using Windows Media Player for
Windows XP, Windows Media Player 9 or Windows Media Player 10
series.
Windows Media is a trademark of Microsoft Corporation.
This product includes technology owned by Microsoft Corporation
and cannot be used or distributed without a license from
Microsoft Licensing, Inc.
About DivX video
DivX is a digital videoformat created by DivX, Inc. This player can
play DiviX videos burned on CD-R/-RW/-ROM discs. Keeping the
same terminology as DVD-Video, individual DivX video files are
called Titles. When naming files/titles on a CD-R/-RW disc prior to
burning, keep in mind that by default they will be played in
alphabetical order.
DivX video compatibility
Official DivX Ultra Certified product.
Plays all versions of DivX video (including DivX 6) with

standard playback of DivX media files.
File extensions: .avi and .divx (these must be used for the player
to recognize DivX video files).Note that all files with the .avi
extension are recognized as MPEG4, but not all of these are
necessarily DivX video files and therefore may not be playable
on this player.
About Windows Media Video (WMV)
WMV is an acronym for Windows Media Video and refers to a video
compression technology developed by Microsoft Corporation. WMV
content can be encoded by using Windows Media Encoder.
This player is compatible with WMV9 files that are encoded by

using the Windows Media Encoder 9 Series, with .wmv as an

extension.
Compatible with size under 720 x 480 pixels/720 x 576 pixels.
Advanced Profile is not supported.
DRM-protected video files will not play in this player.
JPEG file compatibility
Compatible formats: Baseline JPEG and EXIF 2.2* still image
files up to a resolution of 3072 x 2048.
* File format used by digital still cameras.
Progressive JPEG compatible: No
File extensions: .jpg (must be used for the player to recognize
JPEG filesdo not use for other file types)
PC-created disc compatibility
Discs recorded using a personal computer may not be playable in
this unit due to the setting of the application software used to create
the disc. In these particular instances, check with the software
publisher for more detailed information.
Discs recorded in packet write mode (UDF format) are not
compatible with this player.
Check the DVD-R/-RW or CD-R/-RW software disc boxes for
additional compatibility information.
TM
This player can play DivX videos recorded on
DVDs, CDs, or USB storage devices. Keeping
the same terminology as DVD-Video,
individual DivX video files are called Titles.
DivX videos will be played in alphabetical
order.
DivX, DivX Ultra Certified, and associated
logos are trademarks of DivX, Inc. and are
used under license.
11 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
2.4 PANEL FACILITILES
Front panel
1
2 Disc tray
STANDBY/ON
3
4 Display
5 TOP MENU
6 ENTER & cursor buttons
7 MENU
8 RETURN
9 HOME MENU
10 USB port (Type A)
11 DVD/USB
and
12
13
14
Lights when this player is recognized by
another HDMl or DVI/HDCP compatible
component.
15
16 HDMI indicator
Press to switch the player on or into standby.
Press to pause playback. Press again to
restart.
Press to start or resume playback.
Press to stop the disc (you can resume play-
back by pressing
(play)).
Press to open or close the disc tray.
Displays a DVD disc (or DiviX media files) menu
this varies with the disc and may be the same
as the top menu.
Selects the current menu option.
Returns to the previously displayed menu screen.
Display/exit the on-screen display.
Press to turn to USB mode and return to DVD mode.
Skips to the start of the current track, title or
chapter, then to previous tracks/titles/chapters.
Skips to the next track, title or chapter.
Displays the top menu of a DVD disc
this varies with the disc.
OPEN/CLOSE
HDMI
HOME
MENU
RETURN
ENTER
TOP MENU MENU
USB DVD/USB
STANDBY/ON
2 5 3 4 6 7 1
9 8 10 12 11 16 13 14 15
OPEN/CLOSE
12 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
Remote control
Press to switch the player on or into standby.
Press to select the audio channel or language.
Press to select a subtitle option.
Press to display the top menu of a DVD disc.
Use to navigate on-screen displays and
menus. Press ENTER to select an option or
execute a command.
Use for reverse slow motion playback, frame
reverse and reverse scanning.
Press to start or resume playback.
Press to display the Play Mode menu. (You
can also get to the Play Mode menu by
pressing HOME MENU and selecting Play
Mode).
Press to jump to the beginning of the current
Press to enter to the USB REC screen.
Display/exit the on-screen display.
Press to open or close the disc tray.
Press to change the camera angle during
DVD multi-angle scene playback.
Press to clear a numeric entry.
Press to turn to USB mode and return to DVD
mode.
Skips to the start of the current track, title or
chapter, then to previous tracks/titles/chapters.
Press to pause playback; press again to
restart.
Displays a DVD disc (or DiviX media files) menu
this varies with the disc and may be the same
as the top menu.
2 AUDIO
3 SUBTITLE
4 Number buttons
5 TOP MENU
6 ENTER & cursor buttons
7 HOME MENU
and
12 USB REC
13 PLAY MODE
15 ANGLE
16 DVD/USB
17 CLEAR
18 MENU
19 RETURN
23 DISPLAY
24 ZOOM
Press to return to a previous menu screen.
Use for forward slow motion playback, frame
advance and forward scanning.
Press to jump to the next chapter or track.
Press to display information about the disc
playing.
Press to change the zoom level.
13 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
3. BASIC ITEMS FOR SERVICE
3.1 CHECK POINTS AFTER SERVICING
Check points after servicing (DVD player)
To keep the product quality after servicing, confirm recommended check points shown below.
See the table below for the items to be checked regarding video and audio:
Cleaning
Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools:
Pickup lenses Cleaning liquid : GEM1004
Cleaning paper : GED-008
Position to be cleaned Cleaning tools Remark Position to be cleaned Cleaning tools Remark
No. Procedure Check points
1 Confirm the firmware version on Service Mode. The version of the firmware must be latest.
Update firmware to the latest one, if it is not the latest.
The customer complain must not be reappeared.
Video, audio and operations must be normal. 2
Confirm whether the customer complain has been solved.
If the customer complain occurs with the specific disc,
use it for the operation check.
The error rates must be less than 5.0e-4.
3
Confirm playback error rates at the innermost and
outermost tracks by using the following disc.
DVD test disc (GGV1025)
4
Play back a DVD.
(Menu operation, Title/chapter search)
Audio and operations must be normal.
5
Play back a DVD.
(Menu operation, Title/chapter search)
Video, audio and operations must be normal.
6
Check the appearance of the product. No scratches or dirt on its appearance after receiving it
for service.
Items to be checked regarding video Item to be checked regarding audio
Block noise Distortion
Horizontal noise Noise
Dot noise Volume too low
Disturbed image (video jumpiness) Volume too high
Too dark Volume fluctuating
Too bright Sound interrupted
Mottled color
14 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
3.2 PCB LOCATIONS
OPERATION PCB ASSY
POWER PCB ASSY
DVD MT PCB ASSY
DVD MECHA ASSY
Mark No. Description Part No.
LIST OF ASSEMBLIES
1..DVD MT PCB ASSY A2L502A130
1..OPERATION PCB ASSY A2L502A270
(WYXZT5,WVXZT5)
(WSXZT5)
> 1..POWER PCB ASSY A2L502A240
1..DVD MECHA ASSY A2L101A650
15 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
3.3 JIGS LIST
Service Remote Control Unit GGF1381 diagnosis
Name Jig No. Remarks
DVD Test Disc (DVD-Video,NTSC) GGV1025 Operation Check
DVD Test Disc (DVD-Video,PAL)
CD Test Disc
GGV1101
STD-905
Operation Check
Operation Check
Jigs list
Lubricants and Glues list
Daifree GEM1036 (ZLX-ME413A) Refer to "9.3 DVD MECHA SECTION"
Grease GYA1001 (ZLB-PN397B) Refer to "9.3 DVD MECHA SECTION"
Grease GEM1018 Refer to "9.3 DVD MECHA SECTION"

Name Lubricants and Glues No. Remark Name Lubricants and Glues No. Remark
16 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
4. BLOCK DIAGRAM
4.1 OVERALL WIRING DIAGRAM
3
2
1
CP603
3
2
1
CP604
4 3 2 1
C
P
6
0
2
U
S
B

C
O
N
N
E
C
T
O
R 4 3 2 1
C
P
6
0
5
4 3 2 1
C
P
4
0
0
4
1
1
1
0
9 8 7 6 5 4 3 2 1
1
1
1
0
9 8 7 6 5 4 3 2 1
V
o
u
t
B
+
G
N
D
O
S
6
5
1
1 2 3
D
E
G
1
4
9
P
C
B
2
7
0
O
P
E
R
A
T
I
O
N

P
C
B
P
C
B
2
7
1
O
P
E
R
A
T
I
O
N
2

P
C
B
D
E
G
1
5
0
POWER
SW2
GND
3
2
1
3
2
1
C
P
4
0
0
2
1
0
3 2 9 8 7 6 5 4 1
C
D
6
0
1
D
G
N
D
F
L
D
C
+
-
2
8
V
V
+
3
E
I
R
S
T
B
D
O

(
F

t
o

M
)
D
I

(
M

t
o

F
)
C
L
K
D
G
N
D
C
D
6
0
5
4 3 2 1
4 3 2 1
3 2 9 8 7 6 5 4 1
1
1
1
0
1
1
POWER
SW2
GND
+
5
V
G
N
D
U
S
B
_
D
N
U
S
B
_
D
P
C
P
6
0
1
U
S
B
N
U
S
B
P
U
S
B
+
5
V
G
N
D
(
U
S
B
)
U
S
B
N
U
S
B
+
5
V
G
N
D
(
U
S
B
)
U
S
B
P
D
G
N
D
F
L
D
C
+
-
2
8
V
F
L
D
C
-
V
+
3
E
I
R
S
T
B
D
O

(
F

t
o

M
)
D
I

(
M

t
o

F
)
C
L
K
D
G
N
D
F
L
D
C
-
OPERATION
PCB ASSY
(WYXZT5,WVXZT5:A2L502A270)
(WSXZT5:A2L506A270)
2
1
CP8102
2
1
CP8001
2
1
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
16
15
14
13
12
11
10
9
8
7
6
5
4
3
CP501
CONNECTOR
1
2
B
L
A
D
E
W
I
D
E
BLACK
WHITE
2
1
CD501
AC120V_60Hz(US)
OS8101
OPTICAL
1
2
3
H E
J8102
COAXIAL
1 2
DANS LA NOMENCLATURE DES PIECES
N'UTILISER QUE CELLS DECRITES
DANGEREUSES AN POINT DE VUE SEC
ATTENTION:LES PIECES REPAREES PAR UN ETA CAUTION:SINCE THESE PARTS MARKED BY
DESCRIBED IN PARTS LIST ONLY.
CRITICAL FOR SAFETY,USE ONES
ARE
CP5901
HDMI CONNECTOR
1
10
11
12
13
14
15
16
17
18
19
2
3
4
5
6
7
8
9
GND
VCC
INPUT
DMG100
PCB130
DVD MT PCB
DPG017
PCB240
POWER PCB
INTERCONNECTION D
SPDIF
GND
2
1
2
1
SPDIF
GND
NC
NC
D2+
D2-S
D2-
D1+
D1-S
D0+
D0-S
D0-
CLK-S
CLK-
CEC
SCL
SDA
GND
POWER
HOTPLUG
NC
D1-
CLK+
L
N
CP502
P.ON-H(STBY L)
P.CON+12V
P.CON+5V
GND
GND
P.CON+6V
GND(M)
AT+3.3V
AT+3.3V
CP4003_1
FL DC-
FL DC+
-28V
GND(D)
GND(USB)
USB+5V
3
2
9
8
7
6
5
4
1
10
P.ON-H(STBY L)
P.CON+12V
P.CON+5V
FL DC-
FL DC+
GND
GND
P.CON+6V
-28V
GND(M)
GND(D)
AT+3.3V
AT+3.3V
GND(USB)
USB+5V
CD502
16
15
14
13
12
11
16
15
3
2
9
8
7
6
5
4
1
14
13
12
11
10
DVD MT PCB ASSY
(1/7 - 7/7)
(A2L502A130)
POWER PCB ASSY
(1/2,2/2)
(A2L502A240)
J7304
S-VIDEO OUT for HE
1 2
3 4
5 6
H1 H2
E
H1 H2
E
J7302
CVBS/Y/U/V
1
2 3
4
5 6
H2
E
LS/R
1
2 3
17 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
5
4
3
2
1
CP2302
6
5
4
3
2
1
CP2303
24
23
22
21
20
19
2
1
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
CP2301
VRCOM
TRKG DRV
TRKG RTN
FOCS RTN
FOCS DRV
VCC
D
B
VR780(CD)
VRF(RF_OUT)
SW1(DVD/CD)
C
E
VS
F
GND
A
VR650(DVD)
GND
GND
LD_DVD(650)
LD_CD(780)
PD/GND
NC
SW(GND)
LIMIT SW
SLD-
SLD+
SPD-
SPD+
LOAD+
LOAD-
GND
OPEN
CLOSE
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
6
5
4
3
2
1 6
5
4
3
2
1
B
A
VRCOM
VR780(CD)
VRF(RF_OUT)
SW1(DVD/CD)
C
VR650(DVD)
GND
LD_DVD(650)
LD_CD(780)
PD/GND
TRKG DRV
TRKG RTN
FOCS RTN
FOCS DRV
VCC
D
E
VS
F
GND
GND
NC
DM-4PB
DRIVE
DVD
OPTICAL PICK-UP
DED021
PCB610
CD2302
BCZ3B05
M2603
M
5
4
3
2
1
SW-2(CLOSE)
GND(SW)
SW-1(OPEN)
LOADING MOTOR(-)
LOADING MOTOR(-)
2H051602
SSS-28-5
SW1
BCZ3B05
JCV9B12
M2601
M2602
ESE22MH22
SW2
M
M
2H061605
CD2301
DED020
PCB640
SPINDLE MOTOR(+)
SPINDLE MOTOR(-)
FEED MOTOR(-)
GND(SW)
FEED MOTOR(+)
PICK UO INNER LIMIT SWITCH
6
5
4
3
2
1
2 1
2 1
C
P
4
0
0
2
2 1
C
D
6
0
1
D
I

(
M

t
o

F
)
C
L
K
2 1
C
P
6
0
1
D
I

(
M

t
o

F
)
C
L
K
DVD MECHA ASSY
(A2L101A650)
(SW PCB)
(LOADING MOTOR PCB)
MENCLATURE DES PIECES.
QUE CELLS DECRITES
SES AN POINT DE VUE SECURITE
REPAREES PAR UN ETANT
DURING PLAYBACK.
MEASURED WITH THE DIGITAL TESTER
NOTE:THE DC VOLTAGE EACH PART WAS
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE.
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
DMG100
PCB130
DVD MT PCB
ECTION DIAGRAM
B ASSY
30)
J7304
DEO OUT for HE
1 2
3 4
5 6
H1 H2
E
H1 H2
E
J8002
LS/RS/C/LFE
1
2 3
4
5 6
H
1
H
2
E
J8001
L/R
1 2
3
18 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
4.2 OVERALL BLOCK DIAGRAM
P
.
C
O
N
+
1
2
V
A
C
1
2
0
V
V
+
5
H
2
7
M
H
z
-
2
8
V
A
T
+
1
2
V

f
o
r

m
u
t
e
A
T
+
3
.
3
V
P
.
C
O
N
+
6
V
P
.
C
O
N
+
5
V
P
O
W
E
R
S
U
P
P
L
Y
D
V
D

L
O
A
D
E
R
(
D
M
4
)
M
O
T
O
R

D
R
I
V
E
R
I
C
2
3
0
1
A
M
5
7
6
6
F
I
P

D
R
I
V
E
R

I
C

I
C
6
5
1
P
T
6
3
1
5

4
K

E
E
P
R
O
M
I
C
4
0
0
1
S
-
2
4
C
S
0
4
A
F
J
-
T
B
-

G
E
F
I
P
H
N
V
-
0
8
S
S
8
4
K
E
Y
S
E
R
V
O
R
F
S
E
R
V
O
I
R
F
P
,
S
T
B
A
S
P
D
I
F
R E S E T
L
D
_
D
V
D
,
L
D
_
C
D
I
R
1
0
8
M
H
z
T
V

E
n
c
o
d
e
r
M
P
E
G
-
1
/
2
/
J
P
E
G
V
I
D
E
O
D
E
C
O
R
D
E
R
R
F

O
V
E
R
A
L
L

B
L
O
C
K

D
I
A
G
R
A
M
I
R

R
E
C
E
I
V
E
R

(
O
S
6
5
1
)
K
S
M
-
2
0
0
1
T
C
2
P
1
6
M
b
i
t

F
L
A
S
H
I
C
4
0
0
4
E
S
2
9
L
V
1
6
0
E
B
-
7
0
T
G
6
4
M
b
i
t

S
D
R
A
M
I
C
4
0
0
5
M
1
2
L
6
4
1
6
4
A
-
5
T
G
S
D
A
,

S
C
L
A
M
U
T
E
M
P
E
G
/
M
I
C
O
N

B
L
O
C
K
I
C
4
0
0
2
M
T
1
3
8
9
E
X
E
/
S
-
L
A
U
D
I
O

C
O
D
E
C
/
I
N
T
E
R
N
A
L

D
A
C
+
1
.
8
V
A
0
~
A
2
0
,

A
D
0
~
A
D
7
M
A
0
~
M
A
1
1
,

D
Q
0
~
D
Q
1
5
R
E
S
E
T

I
C
I
C
4
0
0
3
R
3
1
1
2
N
2
9
1
A
-
T
R
-
F
A
V
I
D
E
O

D
R
I
V
E
R

6
C
H

I
C
I
C
7
3
0
1
L
A
7
3
0
5
4
-
T
L
M
-
E
4
C
H

V
I
D
E
O

D
A
C
H
D
M
I

C
O
N
N
E
C
T
O
R
C
P
5
9
0
1
T
X
0
+
/
-
,
T
X
1
+
/
-
,
T
X
2
+
/
-
,

T
X
C
+
/
-
C
V
B
S

O
U
T
R
G
B

O
U
T
C
O
C
O
A
X
I
A
L
O
P
T
I
C
A
L
O
P
I
C
8
0
0
3
/
4
/
5
A
U
D
I
O

D
A
C

I
C
P
C
M
1
7
4
2
K
E
/
2
K
D
A
C
_
X
C
S
O
,

S
C
K
,

S
D
,
A
C
L
K
,

A
B
C
K
,

A
L
R
C
K
,

A
S
D
A
T
0
~
2
I
C
8
0
0
2
/
7
/
8
A
U
D
I
O

L
P
F

A
N
D

A
M
P

I
C
R
C
4
5
8
0
I
D
R
C
L
F
E
S
R
L R
F
L
D
C
+
/
-
S
L
2
1

P
I
N
C
V
B
S
V U Y
4
C
H

B
U
S

S
W

I
C
I
C
7
3
0
2
S
N
7
4
C
B
T
3
2
5
7
P
W
R
S
_
Y
S
_
C
19 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
4.3 DVD LOADER/MPEG BLOCK DIAGRAM
D
V
D

L
O
A
D
E
R
/
M
P
E
G

B
L
O
C
K

D
I
A
G
R
A
M
D
V
D
L
o
a
d
e
r
(
D
M
-
4
)
M
P
E
G
/
M
I
C
O
N

I
C
I
C
4
0
0
2
M
T
1
3
8
9
E
X
E
/
S
-
L
X
4
0
0
1
2
7
M
H
z
I
O
A
,

V
2
0
C
R
F
,

A
,

B
,

C
,

D
,

E
,

F
,

M
D
I
1
L
D
_
D
V
D
,

L
D
_
C
D
Q
2
3
0
2
~
2
3
0
5
L
D

D
R
I
V
E
L
D
O
1
,

L
D
O
2
M
O
T
O
R

D
R
I
V
E
R

I
C
I
C
2
3
0
1
A
M
5
7
6
6
D
M
S
O
,

F
M
S
O
,

T
R
O
P
E
N
,

T
R
C
L
O
S
E
,

T
R
S
O
,

F
O
S
O
,

S
T
B
Y
,

V
1
P
4
T
+
/
-
,

F
+
/
-
,
L
O
A
D
+
/
-
,

M
O
T
_
S
L
E
D
+
/
-
,

M
O
T
_
S
P
D
L
+
/
-
O
P
U
S
P
I
N
D
L
E
/
S
T
E
P
I
N
G
/
S
L
E
D
M
O
T
O
R
L
I
M
I
T
,

T
R
I
N
,

T
R
O
U
T
,
O
P
O
,

O
P
+
/
-
1
6
M
b
i
t

F
L
A
S
H
I
C
4
0
0
4
E
S
2
9
L
V
1
6
0
E
B
-
7
0
T
G
M
A
0
~
M
A
1
1
,

D
Q
0
~
D
Q
1
5
,
D
Q
M
0
,

D
Q
M
1
,

D
B
A
0
,

D
B
A
1
,

S
D
C
L
K
,

S
D
C
K
E
,

D
W
E
#
,

D
R
A
S
#
,

D
C
A
S
#
,

D
C
S
#
A

D
A
0
~
A
2
0
,

A
D
0
~
A
D
7
,
P
R
D
#
,

P
C
E
#
,

P
W
R
#
6
4
M
b
i
t

S
D
R
A
M
I
C
4
0
0
5
M
1
2
L
6
4
1
6
4
A
-
5
T
G
A
A
R
E
S
E
T

I
C
I
C
4
0
0
3
R
3
1
1
2
N
2
9
1
A
-
T
R
-
F
A
A
V
I
D
E
O

D
R
I
V
E
R

6
C
H

I
C
I
C
7
3
0
1
L
A
7
3
0
5
4
-
T
L
M
-
E
L
E
T
T
E
R
,

I
/
X
P
,

S
_
Y
,

S
_
C
,
R
/
C
R
,

B
/
C
B
,

G
/
Y
,

C
V
B
S
A
,

B
3 5
Y U
C
V
B
S
/
Y
/
U
/
V
J
7
3
0
2
2
V
1
9
C
V
B
S
2
1
P
I
N

C
O
N
N
E
C
T
O
R
J
8
1
0
1
1
1
1
5
R

O
U
T
G

O
U
T
1
6
7
B

O
U
T
3
L
4
C
H

B
U
S

S
W

I
C
I
C
7
3
0
2
S
N
7
4
C
B
T
3
2
5
7
P
W
R
D
S
Q
U
E
E
Z
E
,

V
S
E
L
1
V
S
E
L
1
6
C
V
B
S
1
R
8
V
S
E
L
1
S
Q
U
E
E
Z
E
2
1

P
I
N

C
T
L
B
L
A
N
K
I
N
G
_
O
U
T
Q
8
1
0
1
,

Q
8
1
0
2
2
1

P
I
N

C
T
L
Q
8
1
0
4
,

Q
8
1
0
5
D
V
D
_
R
G
B
_
H
_
O
U
T
S
D
A
A
.
.
.
.
.
.
.
A
T
+
3
.
3
V
B
.
.
.
.
.
.
.
+
1
.
8
V
C
.
.
.
.
.
.
.
P
.
C
O
N
+
5
V
D
.
.
.
.
.
.
.
P
.
C
O
N
+
6
V
E
.
.
.
.
.
.
.
A
T
+
1
2
V
F
.
.
.
.
.
.
.
P
.
C
O
N
+
1
2
V
G
.
.
.
.
.
.
.
-
2
8
V
H
.
.
.
.
.
.
.
V
+
5
H
E
E
P
R
O
M

I
C
I
C
4
0
0
1
S
-
2
4
C
S
0
4
A
F
J
-
T
B
-
G
E
S
C
L
A
I
R
I
R

R
E
C
E
I
V
E
R

(
O
S
6
5
1
)
K
S
M
-
2
0
0
1
T
C
2
P
I
R
G
R
1
~
G
R
8
,

P
1
~
P
1
6
F
P
_
D
I
,

F
P
_
D
O
,

F
P
_
S
C
K
,

S
T
B
F
I
P

D
R
I
V
E
R

I
C
I
C
6
5
1
P
T
6
3
1
5
F
I
P

(
V
6
5
1
)
H
N
V
-
0
8
S
S
8
4
G
A
A
2 C
O
A
X
I
A
L

J
A
C
K
J
8
1
0
2
C
O
A
X
I
A
L
A
S
P
D
I
F
1
O
P
T
I
C
A
L
O
S
8
0
0
1
O
P
T
I
C
A
L
S
-
V
I
D
E
O

J
A
C
K
J
7
3
0
4
4 3
Y C
C
5 3
S
L
L
F
E
L
S
/
R
S
/
S
/
L
F
E

J
A
C
K
J
8
0
0
2
6
C
2
S
R
L
/
R

J
A
C
K
J
8
0
0
1
3 2
R L
I
C
8
0
0
2
/
7
/
8
A
U
D
I
O

L
P
F

A
N
D

A
M
P

I
C
R
C
4
5
8
0
I
D
R
D
A
C
_
X
C
S
O
,

S
C
K
,

S
D
,
A
C
L
K
,

A
B
C
K
,

A
L
R
C
K
,

A
S
D
A
T
0
~
2
I
C
8
0
0
3
/
4
/
5
A
U
D
I
O

D
A
C

I
C
P
C
M
1
7
4
2
K
E
/
2
K
A
,

C
F
D
2
+
1 3
D
1
+
4
D
1
-
6
D
0
+
7
D
0
-
9
C
L
K
+
1
0
D
2
-
H
D
M
I

C
O
N
N
E
C
T
O
R
C
P
5
9
0
1
C
L
K
-
1
2
H
O
T
P
L
U
G
1
9
P
O
W
E
R
1
8
S
D
A
1
6
1
5
S
C
L
Y O U T
C B O U T
C R O U T
R E S E T
5 6
L
5
9
0
2
7 8
1 4 3 2
5 6
L
5
9
0
1
7 8
1 4 3 2
Q
5
9
0
6
H
I
G
H

S
I
D
E

S
W

I
C
I
C
4
0
0
7
R
5
5
2
3
N
0
0
1
B
-
T
R
-
F
U
S
B
_
F
L
A
G
U
S
B
_
P
_
O
N
-
L
A
S
P
20 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
4.4 POWER BLOCK DIAGRAM
S
W
I
T
C
H
I
N
G
T
R
A
N
S
T
5
0
1
P
.
C
O
N

S
W
Q
5
0
5
A
C

I
N
P
.
C
O
N
+
5
V
A
T
+
3
.
3
V
F
L

D
C

-
-
2
8
V
A
T
+
1
2
V

f
o
r

m
u
t
e
P
.
C
O
N
+
6
V
P
.
C
O
N
+
1
2
V
P
.
O
N
-
H
F
L

D
C

+
Q
5
1
5
P
.
C
O
N

+
5
V

S
W
Q
5
1
0
P
.
C
O
N

+
1
2
V

S
W
Q
5
0
4
F
L
+

P
.
C
O
N

S
W
Q
5
0
2
-
2
8
V

P
.
C
O
N

S
W
V
O
L
T
A
G
E

C
T
L
I
C
5
0
1
K
I
A
4
3
1
A
-
A
T
P
H
O
T
O

C
O
U
P
L
E
R
I
C
5
0
4
P
S
2
5
6
1
A
L
1
-
1
-
V
(
W
)
P
O
W
E
R

C
T
L
I
C
5
0
2
S
T
R
-
A
6
1
5
9
M
6
V

R
E
G
I
C
5
0
3
P
Q
0
7
0
X
F
0
1
S
Z
H
R
E
G
+
1
.
8
V
I
C
4
0
0
6
L
D
1
1
1
7
A
L
-
A
D
J
-
A
A
3
-
A
-
R
+
1
.
8
V
H
D
M
I
+
5
V

R
E
G

I
C
I
C
5
9
0
2
P
Q
1
K
5
0
3
M
2
Z
P
H
V
+
5
H
P
O
W
E
R

B
L
O
C
K

D
I
A
G
R
A
M

21 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
5. DIAGNOSIS
5.1 TROUBLE SHOOTING
POWER DOES NOT TURN ON
Is the voltage at
pin 8 and pin 9 of CP502 about 3.3 V
and at pin 5 of CP502
about 5 V?
No
Yes
No
Is there waveform at
X4001 about 3.0 Vp-p ?
Check X4001, IC4002 and
peripheral circuit.
Yes
Write DVD FIRMWARE DATA.
Check AT+3.3V line of POWER BLOCK.
Check Q515 and peripheral circuit.
No
Yes
No
DECK DOES NOT ACCEPT
OPEN/CLOSE
Check P.CON 6V line of
POWER BLOCK.
Yes
Is the lose connection
at CD2302 to DECK ?
Check CD2302
connection to DECK.
Change DVD LOADER.
Is the voltage at
pin 8 and 19 of IC2301
about DC 6 V ?
22 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
DOES NOT LIGHT ON DISPLAY
Yes
Is the voltage at
pin 13 and pin 43 of IC651
about 3 V ?
Check AT+3.3V line of
POWER BLOCK.
No
Replace V651 or IC651.
NO PLAYBACK PICTURE OF AV
JACK
Is there
video signal at pin 33
of IC7301 ?
Change IC7301.
No
Yes
No
Yes
Check J7302 and peripheral
circuit.
Is there
a signal at pin 187 of
IC4002 ?
Check IC4002 and
peripheral circuit.
23 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
NO DIGITAL AUDIO ON
PLAYBACK OF COAXIAL JACK
Is there
waveform at pin 2 of J8102
about 0.5Vp-p?
Check connection at RCA
Cable.
Yes
Yes
No
No
Change IC4002.
Is there
waveform at pin 215 of IC4002
about 3.3 Vp-p ?
Check Q8103 and
peripheral circuit.
NO ANALOG AUDIO ON
PLAYBACK
Is there
AUDIO signal at pins 7 and 8
of IC8003 ?
Yes
pins 1,2 and 3 of
IC8003 ?
Is there voltage at
pin 6 of IC8003 about 5 V ?
No
Check J8001 and peripheral
circuit.
Yes
Yes
No
No
Check AT+5V
Change IC4002. Change IC8003.
24 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
NO 5.1CH AUDIO ON
PLAYBACK
Is there AUDIO signal at
pins 7 and 8 of IC8003,
IC8004 and IC8005 ?
Yes
pins 1, 2 and 3 of IC8003,
IC8004 and IC8005 ?
Yes
Check J8001, J8002 and
peripheral circuit.
No
No
Check AT+5V.
Change IC4002.
No
Is there voltage at pin 6
of IC8003, IC8004 and
IC8005 about 5 V ?
Yes
Change IC8003,
IC8004 and IC8005.
NO OPTICAL OUT
Check P.CON +D5V line.
Is there voltage at pin
2 of OS8101 about 5 V?
Yes
No
Change OS8101.
No
Yes
Is the waveform at pin 1
of OS8101 about 2.5 V ?
REFER TO "NO DIGITAL
AUDIO ON PLAYBACK OF
COXIAL JACK"
25 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
Symptoms That May Occur When Any Of The Following ICs Is In Failure
IC Symptoms
EEPROM
(DVD MT PCB Assy : IC4001)
User's data cannot be stored in memory.
The ID number is lost.
16M Flash ROM
The power cannot be turned on.
Downloading of the firmware cannot be performed.
DVD IC
Any kind of symptoms (no power, a failure in any of the servo, video and audio systems, etc.) may be
generated, because the DVD processing is performed by a single chip.
64M SDRAM
No power.
Block noise is generated during playback.
26 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
5.2 METHOD FOR DIAGNOSING DEGRADATION OF THE LDS ON THE PICKUP ASSY
C
4
0
4
C
4
0
4
W
8
0
4
R4058
W
8
3
2
W822
C
2
3
0
3
C
2
3
0
2
B
4
0
1
4
NR2301
W
8
4
5
C
4
0
8
6
DMG100A
R
4
0
6
0
C
4
0
7
1
C
4
0
8
0 C
4
0
8
1
C
4
0
8
2
C
5
9
2
1
C
4
0
8
8
C
4
0
6
8
C
4
0
7
2
C
4
0
7
3 C
4
0
5
4
C
4
1
0
1
C
4
1
2
0 C
4
0
5
2
C
4
0
6
4
R
4
0
0
1
C
4
0
5
5
C
4
0
5
1
R
4
0
1
4
R
4
0
0
4
C
4
0
2
2
C
4
0
4
0
C
4
0
2
5
R4044
C
4
0
2
1
R4054
C
4
0
2
9
R
4
0
3
9
C
4
0
3
6
W
8
1
3
C
4
0
3
7
R
4
0
0
3
C
4
0
2
0
C
4
0
0
8
C
4
0
0
9
R
4
0
0
5
C
4
1
0
5
C
4
0
0
5
C
4
0
1
9
C
4
0
1
3
C
4
0
1
7
C
4
0
1
6
C
4
0
1
5
C
4
0
1
4
C
4
0
2
6
W816
R
4
0
2
0
C
4
0
2
7
C
4
0
2
8
C
4
0
3
3
R
4
0
2
2
C
4
0
3
4
C
4
0
3
5
C
4
0
4
1
C
4
0
4
3
C
4
0
4
9
C
4
0
4
8
C
4
0
4
6
C
4
0
6
1
R
4
0
6
9
R
4
0
6
8
C
4
0
8
4
C
4
0
6
5
R
4
0
0
6
R
4
0
0
8
C
4
1
1
0
C
4
0
6
6
C
4
0
6
7
D
7
3
0
9
D
7
3
1
2
D
7
3
0
8
D
7
3
1
1
R
7
3
2
1
D7310
D
7
3
0
7
C
7
3
3
0
B
7
3
0
1
C
7
3
1
7
C
7
3
0
2
C
7
3
1
3
R
7
3
1
5
C
7
3
0
5
R
4
0
6
7
C
4
0
8
3
R
4
0
6
6
C
4
0
7
4
R4065
R4064
R
4
0
6
1
R
4
0
0
2
W
8
0
4
C
8
0
5
4
Q8009
C
8
0
3
0
C
8
0
0
6
R
8
0
9
9
C
8
0
5
1
R
8
0
6
3
R
8
0
6
4
C
8
0
5
5
R8066
C
8
0
6
2
C
8
0
4
6
R
8
0
6
1
R
8
0
7
5
R
8
0
8
7
R
8
0
8
2
Q8019 Q8021
C
8
0
0
5
R
8
0
9
6
Q8010
Q8008
D
8
0
0
3
R
8
0
2
1
D
8
0
0
5
R8002
R8025
C
8
0
3
9
C
8
0
1
3
D
8
0
0
6
R
8
0
0
3
R8017
R
8
0
4
6
R
8
0
1
2
R
8
0
5
4
C
8
0
5
2 C
8
0
5
7
R
8
0
5
8
R
8
0
5
5
C
8
0
4
4
R
8
0
5
2
R
8
0
3
1
R
8
0
4
8
C
8
0
5
6
R
8
0
7
7 Q8017
R8069
R
8
0
7
6
C
8
0
1
0
R
8
0
3
6
C
8
0
4
9
R8053
R
8
0
5
0
C
8
0
5
9
C
8
0
0
9
R
8
0
4
5
R
8
0
6
8
C
8
0
5
3
R
8
0
7
4
Q8015
R
8
0
7
2
R
8
0
9
2
R
8
0
9
3 R4058
W
8
3
2
W822
W
8
2
1
R
4
0
5
0
R4051
C
4
0
3
0
C
4
0
1
2
R4026
C
2
3
0
3
C
2
3
0
2
R
4
0
4
0 W
8
6
8
W
8
1
9
W
8
5
6
R
4
0
0
9
C
4
1
2
8
W807
B
4
0
1
4
C
5
9
0
1
B
4
0
1
5
R8065
B
4
0
1
8
Q4004
C
4
1
3
0
B
4
0
1
6
R
8
0
5
9
W864
W
8
6
2
C
4
1
3
1
NR4003
R
4
0
3
4
NR2301
Q7302
R
4
0
4
8
D4005
W
8
4
4
R
4
0
2
1
C
8
0
2
5
Q5906
C
5
9
2
0
W
8
4
5
R
8
0
6
7
C
8
0
6
3
Q8020
R7304
R
7
3
0
5
R
7
3
1
6
R7317
W
8
4
8
W
8
5
1
W
8
5
0
R8020
Q4002
B
7
3
0
4
C
4
0
8
6
C
4
0
7
5
W
8
5
8
W
8
2
0
W
8
4
0
W878
B8001
R
8
0
0
6
DMG100A
Case when this diagnosis is required :
When playback of any disc, including a test disc (DVD: GGV1025, CD: STD-905), cannot be performed
How to diagnose
In the case mentioned above, degradation of the laser diodes (LDs) mounted on the PICKUP Assy is suspected.
Measure the voltage between the two ends of one of the resistors mentioned below.
Measure the voltage between the two ends of NR2301 on the DVD MT PCB Assy.
If the voltage is 0.17 V or higher, the 650-nm LD is degraded.
No playback of a DVD :
Measure the voltage between the two ends of NR2301 on the DVD MT PCB Assy.
If the voltage is 0.20 V or higher, the 780-nm LD is degraded.
No playback of a CD :
If the measurements show degradation
of an LD, replace the PICKUP Assy.
DVD MT PCB ASSY
27 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
6. SERVICE MODE
6.1 SERVICE MODE PROCEDURE
POWER ON
DSC -
GGF1381
Service mode
remote control
unit
GGF1381
Service mode
remote control
unit
<TRAY OPEN> <TRAY CLOSE>
OPEN/CLOSE
(Player)
OPEN/CLOSE
Press the play key
( ) of the normal
remote control unit.
(Player)
An address is displayed
OR
ESC
<PLAY>
ESC TEST
CHECK
DVD, CD
DVD disc
POWER
ON
OFF
POWER
DISC SET
Notes:
After going into service mode, if you play back the disc, "DISC-NON" is displayed.
The video signal and the audio signal are outputted during the servicemode.
The SKIP key and the SCAN key are effective during the service mode.
SERVICE MODE: PLAY
SERVICE MODE: OFF
28 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
6.2 SERVICE MODE IN
Service Mode Functional Specification
Service mode entry
In the power ON state, press the [ESC] (A8-5F) key and [TEST / RANDOM] (A8-5E) key in order of the Service mode
remote control
unit.
Light the all FL and LEDs.
OSD displays test mode.
Note:
* When pressing the keys of something, the FL displays "NO DISC" and the LED lighting disappears.
, Release the Service mode
Turn off the power.
Press the [ESC] (A8-5F) key of the remote control unit.
LD ON
DVD : Press the [TEST] (A8-5E) and [1] (A8-01) keys in order, and turn on the laser diode (650n).
CD : Press the [TEST] (A8-5E) and [4] (A8-04) keys in order, and turn on the laser diode (780n).
29 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
6.3 DISPLAY SPECIFICATION OF THE SERVICE MODE
Character in bold : Item name
: Information display
1
5
6
10
11
8
9
3
2
12
15
13
14
Address indication
The address being traced is displayed in number.
(as for the DVD, indication of decimal number is
possible.)
DVD : ID indication (hexadecimal number, 8 digits)
[ ]
CD : ID indication [ ]
, Code indication of remote control unit [R ]
In case of double code, display a 2nd code.
Main unit keycode indication [K ]
Tracking status [TRKG ]
Tracking on : [ON]
Tracking off : [OFF]
Spindle status [SPDL ]
[OFF], [CLV]
Mechanism (loading) position value [M ]
Unknown : [01] or [41]
Open state : [04]
Close state : [08]
During opening : [12]
During closing : [22]
Slider position [S ]
In Side Switch ON : [01]
In Side Switch OFF : [00]
Output video system [V ]
NTSC system : [NTSC]
PAL system : [PAL]
Automatic setting : [AUTO]
Scart terminal output [SK ]
(Display only the WY model which can do the output
setting
of scart terminal.)
VIDEO : [00]
S-VIDEO : [01]
RGB : [02]
| Disc sensing [DSC ]
The type of discs loaded is displayed.
[DVD], [CD ], [VCD], [ ]
| Jitter value [J ] Note:Don't use it.
| Version of the FL controller [FL: ]
| Region setting of the player [REG: ]
Setting value : [1] to [6]
| Destination setting of the FL controller
[MDL: / ]
Four characters in the front represent code 01.
Three characters in the back represent the destination
code.
J: /J, K: /KU, /KC, /KU/KC, R: /RL/RD, RAM : /RAM,
LB: /LB, WY: /WY
| Version of the flash ROM [VERSION: ]
7
30 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
6.4 FUNCTIONAL SPECIFICATION OF THE SHORTCUT KEY
Service mode indication (ESC + CHP/TIM keys)
ID Address
The error rate is always displayed in exponential notation, e.g., . e - , for both DVDs and CDs.
EDC/ID/AV 1 error history (ID Address, EDC/ID Error, last eight errors)
Calculation of the average error rate (ESC + "5" [Service mode remote control unit] keys)
The average of the last eight error rates is calculated and indicated in exponential notation. After the calculation is completed, "OK" or "NG" is
displayed. If "NG" is displayed, the disc tray will open (for both DVDs and CDs)
For DVDs: OK with 5.0e-4 or less, for CDs: OK with 7.6e-3 or less
Indication of model information (ESC + CHAP keys)
The items from 12 to 15 of the SERVICE MODE Indications are displayed. However, in the indications, S in the standard test mode is changed
to CHIP VERSION, and M is changed to FL VERSION.
Region confirmation mode (ESC + A.MON [Service mode remote control unit] + "1"-"8" [Service mode remote control unit] keys)
After you press the A.MON key while holding the ESC key pressed and then input the region number, if the number is different from that set in
the unit, an error message is displayed, and the tray opens.
Command Contents Conditions
Remote Control
Key Name
Remote
ControlCode
Memory clear and region / revision indication CLEAR (1) A8-45
Average value measurement of DVD error rate 5 (1) A8-05
CD error rate measurement 5 (1) A8-05
Scart terminal output : VIDEO
WY, models equipped with Scart terminal
AUDIO AF-BE
Scart terminal output : S-VIDEO SUBTITLE AF-36
Scart terminal output : RGB ANGLE AF-B5
Progressive OFF
Only for progressive models
R_SKIP A3-9D
Progressive ON F_SKIP A3-9C
ZOOM ON (X2 -> X4 -> x1) ZOOM AF-37
Service mode indication (error rate indication, etc.) CHP/TIM (1) A8-13
Model information indication CHAP (1) A8-40
Title search Input mode IN
Title No. input
Search execution
SIDE A (1)
Numbers (1)
PLAY (1)
A8-4D
A8-00 to A8-09
A8-17
Region confimation mode
A.MON (1)
Numbers (1)
A8-1E
A8-01 to A8-08
Only during normal playback, the following shortcut keys can be assigned by pressing a required key after pressing the ESC
key of the remote control unit. To quit, press the ESC key
1 : Service mode remote control unit
31 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
6.5 FUNCTIONAL SPECIFICATION OF THE SERVICE MODE
Display during Service Mode
To enter Service Mode, press the CHP/TIM key while holding the ESC key pressed.
To quit, press the ESC key.
Service mode display
1 ID Address
2 Error rate (always displayed), in exponential notation
ERROR RATE :
( )
Calculation of the average error rate
For DVDs: OK with 5.0e-4 or less, for CDs: OK with 7.6e-3 or less
3 EDC/ID error history (ID Address, EDC/ID errors, last eight errors)
Note:
Error of AV1 is not supported in this player.

Number of error
Indication plan contents
Character in bold : Item name
: Information display
1
2
3
ex) For DVDs
Step 1
e-
e -6 : OK
e -5 : OK
e -4 : Refer to Step 2
e -3 : NG
e -2 : NG
Step 2
e -4
3.0e -4 : OK
4.0e -4 : OK
5.0e -4 : OK
6.0e -4 : NG
7.0e -4 : NG
32 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
7. DISASSEMBLY
1. REMOVAL OF MECHANICAL PARTS
AND P.C. BOARDS
1.
2.
3.
4.
Short circuit the position shown in Fig. 1-3 using a
soldering iron. If you remove the DVD Deck with no
soldering, the Laser may be damaged.
Disconnect the following connectors:
(CP2301, CP2302 and CP2303).
Remove the 4 screws (1).
Remove the DVD Deck in the direction of arrow.
1-3: DVD DECK (Refer to Fig. 1-3)
Fig. 1-3
DVD Deck
Short circuit using a
soldering iron.
Pick Up PCB
(1)
(1)
(1)
(1)
NOTE
Before your operation, please read PREPARATION OF
SERVICING.
Use the Lead Free solder.
When Soldering/Removing of solder, use the drawing
equipment over the Pick Up Unit to keep the Flux smoke
away from it.
When installing the DVD Deck, remove all the soldering
on the short circuit position after the connection of Pick Up
PCB and DVD MT PCB connector.
1.
2.
3.
4.
5.
1-4: DVD MT PCB (Refer to Fig. 1-4)
1.
2.
3.
Remove the DVD MT PCB in the direction of arrow.
Fig. 1-4
DVD MT PCB
(1)
(1)
(2)
(2)
(2)
(2)
(1)
(1)
(1)
CAUTION
Be careful not to remove the FFC cable forcibly, because
the FFC cable may be damaged.
1-1:
Remove the Top Cabinet in the direction of arrow (A).
Disconnect the following connectors: (CP4002 and
CP4004).
Unlock the 4 supports (2).
Remove the Front Cabinet in the direction of arrow (B).
Remove the Operation PCB in the direction of arrow (C).
TOP CABINET/FRONT CABINET AND OPERATION
(Refer to Fig. 1-1)
1.
2.
3.
4.
5.
6.
7.
Fig. 1-1
(B)
(A)
Top Cabinet
Front Cabinet
(C)
Operation PCB
Operation PCB
(C)
(1)
(1)
(1)
(1)
(1)
(2)
(2)
(2)
(2)
(3)
(3)
(3)
(3)
(3)
1-2: POWER PCB (Refer to Fig. 1-2)
1.
2.
3.
4.
Disconnect the following connectors:
(CP502 and CP8001).
Remove the Power PCB in the direction of arrow.
Fig. 1-2
Power PCB
(2)
(1)
(2)
(2)
(1)
(3)
(3)
(1)
(1)
33 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
2. REMOVAL OF DVD DECK PARTS
2-1: TRAY (Refer to Fig. 2-1-A)
METHOD AT NO POWER SUPPLY)
Tray.
1. Set the Tray opened. (Refer to the DISC REMOVAL
2. Unlock the 2 supports and draw it while sagging the
Fig. 2-1-A
Tray
Push to Sag
Push to Sag
Loader Ass'y
NOTE
1. In case of the Tray installation, install them as the circled
section of Fig. 2-1-B so that the each markers are met.
2-2: TRAVERSE ASS'Y (Refer to Fig. 2-2-A)
1. Remove the screw .
2. Unlock the 2 supports ,.
3. Remove the Insulator (R) from the Loader Sub Ass'y.
4. Remove the Traverse Ass'y.
Fig. 2-2-A
Tray
Loader Ass'y
Fig. 2-1-B
Insulator (R)
NOTE
1. Disassemble only the DVD DECK PARTS parts listed
here. Minute adjustments are needed if the disassembly
is done. If the repair is needed except listed parts,
replace the DVD MECHA ASS'Y.
NOTE
1. In case of the Traverse Ass'y, install it from (1) to (4) in
2. In case of the Traverse Ass'y installation, hook the wire
order. (Refer to Fig. 2-2-B)
on the Loader Ass'y as shown Fig. 2-2-C.
Traverse Ass'y
Loader Sub Ass'y
Fig. 2-2-B
Check Lock
Traverse Ass'y
Rack Loading
Loader Ass'y (Bottom Side)
Holder Traverse
Fig. 2-2-C
Loader Ass'y
Check Hook
Loading Belt
Loading Sub Ass'y
Gear Pulley
2-3: LOADING MOTOR PCB ASS'Y/ LOADING BELT

(Refer to Fig. 2-3-A)
1. Remove the Loading Belt.
3. Remove the Loading Motor PCB Ass'y.
4. Remove the 2 screws ,.
5. Remove the Loading Motor.
6. Remove the Gear Pulley.
Fig. 2-3-A
Loading Motor PCB Assy
Screw Torque: 2.0 0.3kgfcm
Screw Torque: 2.5 0.3kgfcm (Screw )
Screw Torque: 1.0 0.3kgfcm (Screw ,)
,
,
j,|||,| j,,,,
,
,
34 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
BROWN (1)
WHITE (2)
NOTE
1. In case of the Pulley Motor installation, check if the value
2. When installing the wire of the Loading Motor PCB Ass'y,
3. When installing the Loading Motor PCB Ass'y, install it
4. In case of the Loading Motor PCB Ass'y installation, hook
of the Fig. 2-3-B is correct.
install it correctly as Fig. 2-3-C.
correctly as Fig. 2-3-D.
the wire on the Loader Sub Ass'y as shown Fig. 2-3-E.
Fig. 2-3-B
7.0 0.1 mm
Safety surface for pressing
of the insert.
Loading Motor
Pulley Motor
Check Hook
Fig. 2-3-C
Fig. 2-3-E
Check Hook
Fig. 2-3-D
Rack Loading
B A
The Lever should be position
between A and B.
Check Hook
Rack Loading
Loader Sub Assy

Gear Main
2-4: RACK LOADING/MAIN GEAR/PULLEY GEAR
1. Unlock the support , and remove the Gear Pulley.
2. Remove the Gear Main.
3. Press down the catcher and slide the Rack Loading.
Gear Pulley
,
Fig. 2-4-A
NOTE
1. In case of the Rack Loading installation, hook the Rack
2. When installing the Gear Main, take care the direction of
Loading on the Loader Sub Ass'y as shown Fig. 2-4-B.
up or down as shown Fig. 2-4-C.
Fig. 2-4-B
Rack Loading
Check Hook
Fig. 2-4-C
Main Gear
Up Side
Down Side
2-5: CLAMPER ASS'Y (Refer to Fig. 2-5-A)
clockwise, then unlock the 3 supports .
1. Press the Clamper and rotate the Plate Clamper
2. Remove the Plate Clamper, Magnet Clamper and
Clamper.
Plate Clamper
Magnet Clamper
Fig. 2-5-A
Main Frame
Clamper
Loader Sub Ass'y (Bottom Side)

35 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
Holder Traverse
Insulator (F)
Traverse Ass'y
Insulator (F)
Insulator (R)
NOTE
1. In case of the Clamper Ass'y installation, install correctly
as Fig. 2-5-B.
Fig. 2-5-B
Plate Clamper
Clamper
2-6: HOLDER TRAVERSE/INSULATOR (F)/INSULATOR
1. Remove the Holder Traverse.
2. Remove the 2 Insulator (F).
3. Remove the Insulator (R).
Fig. 2-6-A
(R) (Refer to Fig. 2-6-A)
NOTE
1. In case of the Insulator (F) installation, install correctly
as Fig. 2-6-B.
Fig. 2-6-B
Traverse Holder
Insulator (F)
2-7: SWITCH PCB ASS'Y/GEAR MIDDLE/GEAR FEED/
RACK FEED ASS'Y/FEED MOTOR
1. Unlock the support .
2. Remove the Gear Middle.
3. Remove the screw ,.
4. Remove the Rack Feed Ass'y.
6. Remove the Switch PCB Ass'y.
8. Remove the Gear Feed.
9. Remove the 2 screws .
10. Remove the Feed Motor.
11. Remove the Gear Motor.
Gear Middle
Gear Motor
Feed Motor
Screw Torque: 1.3 0.3 kgfcm (Screw ,)
Screw Torque: 3.0 0.3 kgfcm (Screw )
Screw Torque: 1.0 0.3 kgfcm (Screw , )
Switch PCB Ass'y
,
Rack Feed Ass'y

Gear Feed
Fig. 2-7-A
Traverse Ass'y
NOTE
1. When installing the Rack Feed Ass'y, push both ends to
2. In case of the Gear Motor installation, check if the value
3. When installing the wire of the Switch PCB Ass'y, install
4. After the assembly of the Traverse Ass'y, hook the wire
align the teeth as shown Fig. 2-7-B. Then install it.
of the Fig. 2-7-C is correct.
it correctly as Fig. 2-7-D.
on the Traverse Ass'y as shown Fig. 2-7-E.
[OK] [NG]
Fig. 2-7-B
Rack Feed Ass'y
Push Push
Fig. 2-7-C
8.0 0.2 mm
Safety surface for pressing
of the insert.
Feed Motor
Gear Motor
Check Lock
Pickup leneses
GEM1004
GED-008
36 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
Traverse Ass'y
Check Hook
Check Hook
Check Hook
Fig. 2-7-E
Loosen the wire in the direction of the arrow.
Check Hook
~ FEED MOTOR ~
WHITE (4)
BROWN (3)
~ SPINDLE MOTOR ~
YELLOW (2)
GREEN (1)
Fig. 2-7-D
Switch PCB Ass'y
Install wire from (1) to (4) in order.
[ 24 pin FFC ]
shown from Fig. 2-8.
2-8: FFC WIRE HANDLING
1. When installing the FFC, fold it correctly and install it as
positions for the FFC.
1. Do not make the folding lines except the specified
NOTE
Fig. 2-8
Printing Surface
Fold
79 1 mm
Reinforcement Plate
To Pick Up PCB
37 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
8. EACH SETTING AND ADJUSTMENT
8.1 RE-WRITE FOR DVD FIRMWAVE
1. Purpose
After replacing the DVD MT PCB Assy, be sure to update the firmware to the latest version. The firmware of the Assy for
service may not be the latest.
3. Procedures for updating the firmware
How to update:
1 Turn on the main unit and open the disc tray.
2 Place the disc for updating in the disc tray and close the tray.
3 Press the PLAY button.
4 Updating of the firmware is completed.
2. Procedures for creating the disc for updating
Necessary tools:
1 PC with a CD-R/CD-RW drive
2 Blank CD-R or CD-RW
3 Firmware file (.BIN)
How to create:
1 Start up the program for writing to CD.
2 Load a blank disc in the CD-R/CD-RW drive.
3 Enter "PIONEER" as the volume label.
4 Select the .BIN file.
5 Write the latest version of the firmware in ISO 9660 format.
While the screen shown at left is being displayed, updating is in progress.
DO NOT TURN OFF THE POWER DURING UPDATING.
When the screen with the Pioneer logo is displayed, updating is completed.
The time required for updating is about 2 minutes.
38 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
4. How to confirm the version of the firmware
Press the ESC then the CHAP key on the remote control unit for servicing. The version of the firmware is labeled ROM
NUMBER. Check if the version is the latest one.
YJC8223A
AREA:WY
20
02A6
1.16
1389FE
ROM NUMBER
REGION:2
REG CHK
SUM CHK
FL VERSION
CHIP VERSION
How to interpret the version code:
Number of releases on the same release date
Release date:(Example:2008.2.23)
8: Year
2: Month (1-9 [Jan-Sep], A-C [Oct-Dec])
23: Day
Fixed
Y J C 8 2 2 3 A
5. Troubleshooting
If updating of the firmware failed
If the main unit was turned off during updating, it cannot initialize and start up again properly. In such a case, replace the
flash ROM on the DVD MT PCB Assy.
, If updating of the firmware using the disc for updating failed
Was the disc for updating recognized properly?
Check if the volume label of the disc is PIONEER.
Is playback of a disc other than the disc for updating possible?
If playback of a test CD is also impossible, a reading section, such as PU, may be defective. In such a case, repair the
defective part first.
If playback of a test CD is possible, the disc for updating may be defective. Check for any scratches or foreign matter,
such as fingerprints, on the reading surface.
If no problem is found with the disc, create a new disc for updating again.
39 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
40 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
9. EXPLODED VIEWS AND PARTS LIST
9.1 PACKING
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Screws adjacent to mark on product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions, apply as you think it appropriate.)
NOTES:
WVXZT5
Only
Except
WVXZT5
WSXZT5 Only
WVXZT5 Only
41 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
(1) PACKING SECTION PARTS LIST
(2) CONTRAST TABLE
DV-610AV-S/WYXZT5, /WVXZT5, /WSXZT5, DV-610AV-K/WYXZT5 and WSXZT5 types are constructed the same
except for the following:
> 1 Power Cable See Contrast table (2)
2 Audio/Video Cable 06CPBA2006
3 Remote Control See Contrast table (2)
4 Package Pad 792WHAA237
5 . . . . . . . .
6 Operating Instructions (E) See Contrast table (2)
7 Operating Instructions (E/I) See Contrast table (2)
8 Operating Instructions (G/F) See Contrast table (2)
9 Operating Instructions (S/D) See Contrast table (2)
10 Operating Instructions (R) See Contrast table (2)
11 . . . . . . . .
12 . . . . . . . .
13 Package See Contrast table (2)
14 Gift Box See Contrast table (2)
Mark No. Symbol and Description
DV-610AV-S/
WYXZT5
DV-610AV-S/
WVXZT5
DV-610AV-S/
WSXZT5
DV-610AV-K/
WYXZT5
DV-610AV-K/
WSXZT5
> 1 Power Cable 1206158802 1206138802 1206158802 1206158802 1206158802
3 Remote Control 076E0PP121 076E0PP121 076E0PP121 076E0PP131 076E0PP131
6 Operating Instructions (English) Not used J2L50501A Not used Not used Not used
7 Operating Instructions J2L50221A Not used Not used J2L50221A Not used
(English, Italian)
(German, French)
(Spanish, Dutch)
10 Operating Instructions (Russian) Not used Not used J2L50601A Not used J2L50601A
13 Package 792WHAA252 792WHAA253 792WHAA252 792WHAA252 792WHAA252
14 Gift Box 793WCDD677 793WCDD788 793WCDD775 793WCDD714 793WCDD774
42 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
9.2 EXTERIOR SECTION
4
A
B
D
A
C
B
D
C
43 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
(1) EXTERIOR SECTION PARTS LIST
(2) CONTRAST TABLE
DV-610AV-S/WYXZT5, /WVXZT5, /WSXZT5, DV-610AV-K/WYXZT5 and WSXZT5 types are constructed the same
except for the following:
1 DVD MT PCB Assy A2L502A130
2 OPERATION PCB Assy See Contrast table (2)
3 . . . . . . . .
> 4 POWER PCB Assy A2KL502A240
5 DVD MECHA ASSY A2L101A650
6 Shield,21Pin 761WSA0237
7 . . . . . . . .
8 . . . . . . . .
9 Plate,Cover power 755WPAA035
10 Holder,FFC 761WPA0396
11 Cushion,Leg VEB1349
12 Cabinet,Top See Contrast table (2)
13 Spring Earth 743WKAA015
14 Cushion 65TS10-7.5 8965TS0610
15 . . . . . . . .
16 Screw,Tap Tite(B)-R (3x5.5) 815223055U
17 Screw,Tap Tite(B) (3x6.0) See Contrast table (2)
18 Screw,Tap Tite(B)Pan (3x6) 810913060U
19 Screw,Tap Tite(P) (2.6x8) 811022680U
20 Screw,Tap Tite(P) Bind WH7 8110I2680U
21 Screw Pan 810213060U
22 Sheet DVD 723674A001
23 Front Cabi Assy See Contrast table (2)
24 Flap, DVD 712WPAA171
25 Spring, Flap-DVD 743WKA0052
26 Cord Connector (CD502) 06E82G3301
27 Cord Jumper (CD601) 122H0B1003
28 Cord Jumper (CD7301) 122H0C3002
29 Cord Jumper (CD605) 06CU241203
30 Flat Cable WAL6815038
31 Spring Earth 753WUAA013
Mark No. Symbol and Description
DV-610AV-S/
WYXZT5
DV-610AV-S/
WVXZT5
DV-610AV-S/
WSXZT5
DV-610AV-K/
WYXZT5
DV-610AV-K/
WSXZT5
2 OPERATION PCB Assy A2L502A270 A2L502A270 A2L506A270 A2L502A270 A2L506A270
12 Cabinet, Top 702WSBA075 702WSBA075 702WSBA075 702WSBA076 702WSBA076
17 Screw,Tap Tite(B) (3x6.0) 810923060U 810923060U 810923060U 810923060S 810923060S
23 Front Cabi Assy 7A701B096A 7A701B096A 7A701B096A 7A701B0173A 7A701B173A
44 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
9.3 06 DVD MECHA SECTION
Applying positions AA, AB and AC for the
grease are displayed for this section.
Check if the correct grease is applied for each
position.
NOTE:
CLASS MARK
GREASE AA
AB
PART NO.
GEM1018
GYA1001
AC GEM1036
Cannot supply separately.
If the repair is needed, replace the
LOADER SUB ASS'Y.
PCB610
(LOADING MOTOR PCB ASS'Y)
CD2302
Do not replace the parts. Because,
minute adjustments are needed if
this condition is disassembled
further more.
If the repair is needed, replace the
DVD MECHA ASS'Y.
(SW PCB ASS'Y)
AB
AB
AB
AA
AB
AB
AB
SW1
PCB640
CD2001
SW2
CD2301
AC
AC
AB
Lubricating Oil
GYA1001
Daifree
GEM1036
Pickup leneses
GEM1004
GED-008
Grease
GEM1018
Note :
Lubricating Oil
GYA1001
45 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
06 DVD MECHA SECTION PARTS LIST
1 . . . . . . . .
2 Gear,Middle 92P100117A
3 Loading Motor 1515S98004
4 Pulley,Motor 92P100097A
5 FEED Motor 1515S98004
6 Cord Jumper (CD2001) 12C14O2202
7 Cord Jumper (CD2302) 12C1051601
8 Insulator (F) 92P200013A
9 Belt,Loading 92P200015A
10 Insulator (R) 92P200016A
11 Frame,main 92P100119A
12 Tray (R) 92P100151A
13 Holder ,Traverse 92P100125A
14 Gear,Pulley 92P100123A
15 Gear,Main 92P100124A
16 Gear,Feed 92P100116A
17 . . . . . . . .
18 Plate, Clamper 92P000023A
19 LOADER SUB ASSY (R) 92AAA0024A
20 Clamper 92P100122A
21 Screw,Pan (M1.7x3 P3) 814011730U
22 Screw,Pan (M1.7x2.3 P3) 814011723U
23 Rack,Loading 92P100121A
24 Gear,Motor 92P100088A
25 Feed Rack Assy 92AAA0017A
26 Screw,T-Tite(B) (M1.7x5.0 P3) 813381750U
27 Screw,Gear Feed 92P700007A
28 Cord Jumper (CD2301) 12C1061601
29 Switch (SW1) 0515S32003
30 Push Switch (SW2) 0500101036
31 Screw,Tap Tite(P) (2.6x8) 811022680U
32 Sems.Tap Tite(P) (2x8) 816112080U
33 Screw (Bind 2x8) 811022080U
46 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
10. SCHEMATIC DIAGRAM
10.1 DVD MT PCB ASSY(1/7)
IC4002
MT1389EXE/S-L
MPEG/MICON IC
101102103104105106107
214 215 216 217 218 219 220 221 222 223 224 225 226 227 228 229 230 231 232 233 234 235 236 237 238 239 240 241 242 243 244 245 246 247 248 249 250 251 252 253 254 255 256
1
1
0
100
1
1
1
2
1
3
1
4
1
5
1
6
1
7
1
8
1
9
2
2
0
2
1
2
2
2
3
2
4
2
5
2
6
2
7
2
8
2
9
3
3
0
3
1
3
2
3
3
3
4
3
5
3
6
3
7
3
8
3
9
4
4
0
4
1
4
2
4
3
4
4
4
5
4
6
4
7
4
8
4
9
5
5
0
5
1
5
2
5
3
5
4
5
5
5
6
5
7
5
8
5
9
6
6
0
6
1
6
2
6
3
6
4
65 66 67 68 69
7
70 71 72 73 74 75 76 77 78 79
8
80 81 82 83 84 85 86 87 88 89
9
90 91 92 93 94 95 96 97 98 99
R
4
0
2
2
1
0
0
K
R
4
0
3
5
3
3
R
4
0
0
1
1
0
K
R4046 10
R
4
0
1
4
1
0
K
R4059
10K
R4050 33
R4047 33
R4039
5.1K +-1%
R
4
0
4
3
3
3
R
4
0
4
0
3
3
R
4
0
3
8
3
3
R4024
750K
R4015 13K+-1%
R4016 8.2K +-1%
R4017 22K
R4018 13K+-1%
R4019 13K+-1%
R4026
6.8
R4025
100K
R
4
0
0
4
1
0
K
R
4
0
0
5
6
8
0
K
R
4
0
2
7
1
0
0
R4020 15K
R4054 10K
T
P
4
0
3
4
T
P
4
0
3
3
T
P
4
0
1
5
T
P
4
0
1
6
T
P
4
0
1
7
T
P
4
0
1
8
T
P
4
0
1
9
T
P
4
0
2
0
T
P
4
0
2
1
T
P
4
0
2
2
T
P
4
0
2
3
T
P
4
0
2
5
T
P
4
0
2
4
T
P
4
0
2
6
T
P
4
0
2
7
T
P
4
0
2
8
T
P
4
0
3
1
T
P
4
0
3
2
T
P
4
1
0
3
T
P
4
0
1
4
TP4013
TP4011
T
P
4
0
3
0
T
P
4
0
2
9
T
P
4
0
4
4
TP4012
TP4109
TP4107
TP4108
TP4009
TP4007
TP4001
TP4002
TP4003
TP4004
TP4005
TP4006
TP4008
TP4010
TP4036
W816
W
8
3
3
W851
W
8
0
7
W
8
3
0
W858
(R4053)
W815
W813
C
4
0
3
4
2
0
P
C
H
C4075
56P CH
C
4
0
2
0
0
.
1
B
C
4
0
6
3
1
0
(
2
1
2
5
)
B
C
4
0
4
9
1
1
P
C
H
C4019
0.1 B
C
4
0
4
3
0
.
1
B
C
4
0
2
4
0
.
0
0
1
5
B
C4013 0.1 B
C
4
0
0
7
0
.
1
B
C4047
0.001 B
C
4
0
4
4
0
.
0
4
7
B
C
4
0
4
2
0
.
0
4
7
B
C
4
0
3
1
0
.
0
3
3
B
C
4
0
3
2
0
.
1
B
C4021
0.1 B
C
4
0
5
1
0
.
1
B
C4028
0.1 B
C4014 1 B
C4015 1 B
C4016 1 B
C4017 1 B
C4103 1 B
C
4
0
2
5
0
.
1
B
C4026
0.1 B
C
4
0
5
5
0
.
1
B
C
4
1
3
1
1
0
0
P
C
H
C
4
0
2
2
0
.
1
B
C4005
0.1 B
C
4
1
0
5
0
.
0
0
2
2
B
C
4
0
0
9
0
.
0
1
5
B
C
4
0
0
8
0
.
1
B
C
4
0
0
3
2
7
0
P
C
H
C
4
0
0
2
2
7
0
P
C
H
C
4
0
0
1
0
.
0
0
2
2
B
C4033
0.001 B
C
4
0
3
5
0
.
1
B
C
4
0
4
1
0
.
1
B
C
4
0
4
6
0
.
1
B
C4027 0.1 B
C
4
0
3
8
0
.
1
B
C
4
0
3
7
4
.
7
(
2
1
2
5
)
B
C
4
0
1
2
1
0
(
2
1
2
5
) B
C
4
0
2
9
0
.
1
B
C
4
0
6
1
4
.
7
(
2
1
2
5
)
B
C
4
0
4
8
1
2
P
C
H
C
4
0
3
6
0
.
1
B
C
4
0
3
0
1
0
(
2
1
2
5
) B
I
C
4
0
0
1
S
-
2
4
C
S
0
4
A
F
J
-
T
B
-
G
E
E
E
P
R
O
M

4
K

I
C
1 2 3 4
5 6 7 8
C
4
0
6
0
1
0
0
0
6
.
3
V
Y
K
_
P
C
4
0
2
3
4
7
0
6
.
3
V
Y
K
_
P
X4001
100GT02720
27MHz
Q4004
KTC3875S_Y_RTK
STBY POWER CTL
B
4
0
1
6
E
B
M
S
1
6
0
8
0
8
A
1
0
2
_
R
D
C
4
5
B
4
0
1
4
E
B
M
S
1
6
0
8
0
8
A
1
0
2
_
R
D
C
4
5
B
4
0
1
8
E
B
M
S
1
6
0
8
0
8
A
1
0
2
_
R
D
C
4
5
B4010
BLM18BD102SN1
N
R
4
0
0
1
4
D
0
3
W
G
J
0
3
3
0
T
5
E
N
R
4
0
0
3
4
D
0
3
W
G
J
0
1
0
3
T
5
E
V
1
P
4
V
+
3
V
+
3
A
C
L
K
A
B
C
K
V
+
3
D
V
+
1
R
8
D
A
L
R
C
K
A
S
D
A
T
0
A
S
D
A
T
1
A
S
D
A
T
2
A
D
A
C
_
G
N
D
A
B
C
D
E
F
MDI1
LDO1
LDO2
V1P4
DMSO
FMSO
TRCLOSE
TROPEN
TRSO
FOSO
OPO
OP+
OP-
TROUT
TRIN D
STBY
A
V20
LIMIT
B
IOA
C
RF RF
D_GND
E
F
MDI1
LDO2
LDO1
FP_DO
STB
FP_DI
FP_SCK
V+3D
V20
USB_P_ON-L
USB_FLAG
V1P4
USBP
USBN
USB_GND
IR
MA0
MA1
MA2
MA3
OPO
MA4
OP-
MA5 OP+
MA6
DMSO
MA7
MA8
FMSO
MA9
TROPEN
MA10
MA11
TRSO
SDCKE
SDCLK
FOSO
DBA0
DBA1
DCS#
USBP
DRAS#
DCAS#
USBN
DWE#
V+3D
DQM0
DQM1
DQ0
DQ1
V+1R8D
DQ2
DQ3
DQ4
DQ5
USB_P_ON-L
DQ6 USB_FLAG
DQ7
DQ8
DQ9
IOA
DQ10
DQ11 A2
DQ12
A3
DQ13
DQ14
A4
DQ15
A5
A0 A6
A1
A7
A2
A3
A8
A4
A18
A5 A19
A6
A7
V+3D
A8
A9
U
W
R
#
U
R
D
#
A10
SDA
A11
SCL
A12
A13
A14
A15
A16
A17
A18
A19
A20
AD0
AD1
AD2
AD3
P
W
R
#
A
1
6
A
1
5
A
1
4
A
1
3
A
1
2
A
1
1
A
1
0
A
2
0
P
C
E
#
P
R
D
#
A
D
0
A
D
1
A
D
2
A
D
3
A
D
4
A
D
5
A
D
6
A
D
7
A
1
7
AD4 A
9
A
1
A
0
AD5
AD6
AD7
PWR#
F
P
_
S
C
K
V
+
1
R
8
D
F
P
_
D
I
F
P
_
D
O
PCE#
S
T
B
S
C
L
S
D
A
R
X
D
T
X
D
PRD#
FROM/TO MEMORY/USB
FROM/TO LOADER/MOTOR DRIVE
NC
NC
NC NC
1.47
0.6
3.18
NCNC NC
65
66
67
68
254
253
255
256
XIOWR
RFGC
IREF
AVDD3
AGND
DVDA
DVDB
DVDC
DVDD
DVDRFIP
MA
MB
MC
MD
SA
SB
SC/TNI
SD/TPI
MDI1
MDI2
LDO2
LDO1
SVDD3
RFLVL/RFON
SGND
CSO/RFOP
V2REF
V20
VFEFO
EFO
TEO
TEZISLV
OP_OUT
OP_INN
OP_INP
DMO
FMO
TROPENPWM
PWMOUT1/_ADIN0
TRO
FOO
AGND18_DMPLL
AVDD18_DMPLL
USB_DP
USB_DM
VDD33_USB
VSS33_USB
PAD_VRT
VDD18_USB
VSS18_USB
USB_XTALO/GPIO15
USB_XTALI/GPIO14
FG/GPIO16
IOA22/GPIO18
DVDD18
IOA2
IOA3
IOA4
IOA5
IOA6
IOA7
HIGHA0
IOA18
IOA19
DVDD33
A16
HIGHA7
I
O
A
2
0
I
O
A
0
I
C
E
A
D
A
C
V
D
D
3
X
T
A
L
O
HRZFC
CRTPLP
RFGND
OSP
R
F
R
P
A
C
R
F
R
P
D
C
R
F
V
D
D
3
A
D
C
V
S
S
A
D
C
V
D
D
3
L
P
F
O
P
L
P
F
I
P
L
P
F
I
N
P
L
L
V
D
D
3
P
L
L
V
S
S
L
P
F
O
N
J
I
T
F
N
J
I
T
F
O
R
F
V
D
D
1
8
R
F
G
N
D
1
8
X
T
A
L
I
S
A
D
C
V
S
S
1
8
S
A
D
C
V
D
D
1
8
A
D
A
C
V
S
S
3
C
H
7
C
H
8
A
D
A
C
V
D
D
1
A
D
A
C
V
D
D
2
C
E
N
T
E
R
A
L
S
A
L
A
V
C
M
A
R
A
R
S
L
F
E
A
D
A
C
V
S
S
1
A
D
A
C
V
S
S
2
A
P
L
L
C
A
P
A
P
L
L
V
S
S
A
P
L
L
V
D
D
G
P
I
O
1
2
S
P
D
I
F
/
G
P
I
O
2
3
U
P
3
_
5
/
T
X
D
U
P
3
_
4
/
R
X
D
U
P
3
_
1
U
P
3
_
0
U
P
1
_
7
/
S
D
A
U
P
1
_
6
/
S
C
L
U
P
1
_
5
/
V
S
D
A
U
P
1
_
4
/
V
S
T
B
U
P
1
_
3
/
V
S
C
K
U
P
1
_
2
/
G
P
I
O
1
9
D
V
D
D
3
3
X
U
R
D
X
U
W
R
D
V
D
D
1
8
A
1
7
D
V
S
S
3
3
A
D
7
A
L
E
I
O
A
2
1
/
G
P
I
O
1
7
A
D
6
A
D
5
A
D
4
A
D
3
A
D
2
D
V
S
S
1
8
A
D
1
A
D
0
X
I
O
O
E
I
O
A
1
X
I
O
C
S
H
I
G
H
A
1
H
I
G
H
A
2
H
I
G
H
A
3
H
I
G
H
A
4
H
I
G
H
A
5
H
I
G
H
A
6
I
O
C
E
#
I
O
W
R
#
R
F
V
3
3 RFVDD3
PLLVDD3
N
C
N
C
V
C
C
S
C
L
W
P
S
D
A
N
C
N
C
N
C
G
N
D
W
P
S
D
A
N
C
N
C
N
C
G
N
D
0 0 0 0
3
.
3
3
.
3
3
.
3
0
OSN
1.1
0.9
0
0
0
0
1.6
2.2
2.2
2.2
2.2
2.0
2.0
0.2
0.2
2.5
3.3
3.3
0
0
0
2.7
2.0
1.4
1.3
1.3
1.3
1.2
1.7
1.6
1.9
1.3
0
1.4
1.3
1.4
0
1.9
0
0
3.3
0
0.8
1.9
0
3.3
3.7
0
0
1.9
2.0
2.1
2.1
1.9
2.1
2.6
2.3
2.3
0
3
.
3
3
.
3
3
.
3 0
0
.
5
1
.
7
3
.
3
1
.
9
1
.
9
2
.
1
1
.
1
2
.
0 0 0
1
.
9 0
1
.
8
1
.
8 0
1
.
1
1
.
1
1
.
4
1
.
5
1
.
3
0
.
1
1
.
2
1
.
2 0 0
2
.
1
1
.
8
3
.
2
3
.
2
3
.
3
3
.
2
3
.
2
3
.
1
3
.
2
3
.
3 0
3
.
0
3
3
3.3
0
1.4
0 0 1
.
5
0 1
.
7
1
.
5
1
.
3
1
.
6
3
.
3
0 3
.
3
1
.
4
1
.
5
1
.
7
1
.
5
3
.
2
0
.
8
0
.
6
1
.
0
0
.
5
1
.
9
0 1
.
9
3
.
3
0 0 0 3
.
3
3
.
3
0 1
.
6
1
.
0
1
.
6
0 0 0 1
.
3
3
.
3
1
.
7
W857
1 4
47 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
101102103104105106107108109110111112113114115116117118119120121122123124125126127128
1
2
9
1
3
0
1
3
1
1
3
2
1
3
3
1
3
4
1
3
5
1
3
6
1
3
7
1
3
8
1
3
9
1
4
0
1
4
1
1
4
2
1
4
3
1
4
4
1
4
5
1
4
6
1
4
7
1
4
8
1
4
9
1
5
0
1
5
1
1
5
2
1
5
3
1
5
4
1
5
5
1
5
6
1
5
7
1
5
8
1
5
9
1
6
0
1
6
1
1
6
2
1
6
3
1
6
4
1
6
5
1
6
6
1
6
7
1
6
8
1
6
9
1
7
0
1
7
1
1
7
2
1
7
3
1
7
4
1
7
5
1
7
6
1
7
7
1
7
8
1
7
9
1
8
0
1
8
1
1
8
2
1
8
3
1
8
4
1
8
5
1
8
6
1
8
7
1
8
8
1
8
9
1
9
0
1
9
1
1
9
2
193 194 195 196 197 198 199 200 201 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220 221 222 223 224 5
100 97 98 99
R
4
0
3
5
3
3
R
4
0
0
1
1
0
K
R4002
2.2K +-1%
R4061 51K
R4084
4.7K
R4003 33K
33
33
R
4
0
4
3
3
3
R
4
0
4
0
3
3
R
4
0
3
8
3
3
R
4
0
0
8
1
0
K
R
4
0
0
6
1
0
K
R4064 150+-1%
R4065 150+-1%
R4066 150+-1%
R4067 150+-1%
R4068 150+-1%
R4069 150+-1%
R4083 47
R4082 33
R4034
100
R4051 220
R4071 33
R4070 33
R4060 33
R4009
2.7K +-1%
TP4110
T
P
4
1
0
6
T
P
4
0
4
8
T
P
4
0
5
1
T
P
4
0
5
2
T
P
4
0
5
3
T
P
4
0
5
4
T
P
4
0
5
5
T
P
4
0
5
6
T
P
4
0
5
7
T
P
4
0
5
8
T
P
4
0
5
9
TP4087
TP4082
TP4081
TP4079
TP4080
TP4078
TP4076
TP4077
TP4088
TP4075
TP4073
TP4074
TP4072
TP4070
TP4071
TP4069
TP4083
TP4084
TP4085
TP4086
TP4061
TP4060
TP4067
TP4062
TP4068
TP4066
T
P
4
0
6
3
T
P
4
0
9
0
T
P
4
0
4
4
T
P
4
0
4
6
T
P
4
0
4
9
T
P
4
0
8
9
T
P
4
0
6
5
TP4040
TP4104
TP4042
TP4105
W
8
0
4
W846
W
8
0
7
W
8
5
0
W820
C
4
0
6
3
1
0
(
2
1
2
5
)
B
C4068
0.1 B
C
4
1
1
0
1
0
0
P
C
H
C4069
0.0056 B
C
4
0
2
4
0
.
0
0
1
5
B
C
4
0
5
4
2
2
0
P
C
H
C4091
1 B
C4082
0.1 B
C
4
0
8
4
0
.
1
B
C
4
0
6
4
0
.
1
B
C4088
0.1 B
C4083
0.1 B
C4080
0.1 B
C4074
0.1 B
C
4
0
6
6
1
B
C
4
0
6
7
0
.
1
B
C
4
0
6
5
0
.
1
B
C
4
1
1
7
1
0
0
P
C
H
C4104
0.01 B
C4071
0.1 B
C4128
0.01 B
0
.
1
B
C
4
1
3
1
1
0
0
P
C
H
C4081
0.1 B
C4072
0.1 B
C4073
0.1 B
C4130
0.1 B
C4011
47 16V
YK_P
C
4
0
2
3
4
7
0
6
.
3
V
Y
K
_
P
I
C
4
0
0
3
R
3
1
1
2
N
2
9
1
A
-
T
R
-
F
A
R
E
S
E
T

I
C
1 2 3
4 5
B4015
EBMS160808A102_RDC45
B
4
0
0
7
B
L
M
1
8
B
D
2
2
1
S
N
1
D
B
4
0
1
4
E
B
M
S
1
6
0
8
0
8
A
1
0
2
_
R
D
C
4
5
10
SN1
S D
G
Q4002
2SK3019_TL
SW
NR4002
4D03WGJ0330T5E
N
R
4
0
0
1
4
D
0
3
W
G
J
0
3
3
0
T
5
E
DURING PLAYBACK.
V
+
3
S
D
S
C
K
V
+
3
A
A
C
L
K
A
B
C
K
A
S
P
D
I
F
S
T
B
Y
T
R
I
N
I
/
X
P
V
+
1
R
8
A
L
R
C
K
X
M
M
U
T
E
X
A
M
U
T
E
V
S
E
L
1
P
W
D
N
#
T
R
O
U
T
V
+
1
R
8
V
+
1
R
8
D
A
S
D
A
T
0
A
S
D
A
T
1
A
S
D
A
T
2
D
A
C
_
X
C
S
0
T
R
C
L
O
S
E
L
E
T
T
E
R
S
Q
U
E
E
Z
E
A
D
A
C
_
G
N
D
SD
SCK
DAC_XCS0
VSEL1
XAMUTE
LETTER
XMMUTE
SQUEEZE
ALRCK
I/XP
V
+
3
V
ABCK
R/CR
ACLK
B/CB
ASDAT0
G/Y
ASDAT1
CVBS
ASDAT2
S_C
ASPDIF
S_Y
D_GND
D_GND
V+5H
S_Y
V+3H
DVDD18
S_C
PWDN#
V+1R8
V+3
CVBS
V+3A
ADAC_GND
G/Y
D_GND
B/CB
R/CR
TX2+
TX2-
TX1+
V+3D
TX1-
HDMI_SDA
HDMI_SCL
TX0+
HPD TX0-
TXC-
TXC+
TXC+
TXC-
TX0-
TX0+
DVDD18
TX1-
TX1+
TX2-
TX2+
A_GND
V+3H
V+5H
HDMI_SCL
HDMI_SDA
HPD
MA4
MA5
MA6
MA7
MA8
MA9
MA11
SDCKE
SDCLK
V+3D
RXD
MA3
TXD
MA2
D_GND
MA1
MA0
MA10
DBA1
DBA0
DCS#
DRAS#
DCAS#
DWE#
DQM1
LIMIT
DQ8
D
Q
1
5
D
Q
1
4
D
Q
1
3
D
Q
1
2
D
Q
1
1
D
Q
1
0
D
Q
9
D
Q
M
0
D
Q
7
D
Q
6
D
Q
5
D
Q
4
D
Q
3
D
Q
2
D
Q
1
D
Q
0
RESET
F
P
_
S
C
K
F
P
_
D
I
F
P
_
D
O
V
+
3
V
+
3
D
S
T
B
S
C
L
S
D
A
R
X
D
T
X
D
I
R
FROM/TO HDMI
FROM/TO POWER PORT
TO VIDEO
TO AUDIO/JACK
PCB130
DMG100
MPEG/MICON/DSP SCHEMATIC DIAGRAM
NC NC
3.10
4.88
3.2
NCNC NCNC
NC
127
128
192
191
190
189
I
C
E
X
R
E
S
E
T
I
R R
D
7
R
D
6
R
D
5
R
D
4
R
D
3
D
V
D
D
3
3
R
D
2
R
D
1
R
D
0
R
D
1
5
RD10
RD9
DQM1
XRCS
RA10
RA2
RCLK
CKE
RA9
RA8
TXCN
TXCP
TX0P
TX1P
TX2P
C
DACVDDB
Y
D
A
C
V
D
D
C
A
V
C
M
A
R
A
R
S
L
F
E
A
D
A
C
V
S
S
1
A
D
A
C
V
S
S
2
A
P
L
L
C
A
P
A
P
L
L
V
S
S
A
P
L
L
V
D
D
G
P
I
O
1
1
G
P
I
O
1
2
S
P
D
I
F
/
G
P
I
O
2
3
D
V
D
D
1
8
G
P
I
O
1
0
G
P
I
O
9
T
S
_
E
R
R
O
R
D
V
D
D
3
3
T
S
_
P
W
M
T
S
_
S
Y
N
C
T
S
_
C
L
K
T
S
_
V
A
L
I
D
T
S
_
D
A
T
A
7
T
S
_
D
A
T
A
6
T
S
_
D
A
T
A
5
T
S
_
D
A
T
A
4
T
S
_
D
A
T
A
3
T
S
_
D
A
T
A
2
T
S
_
D
A
T
A
1
T
S
_
D
A
T
A
0
V
R
E
F
DACVSSC
CVBS
DACVDDA
G
DACVSSA
B
R
TX2N
AVDD18_TX0
AGND18_TX0
TX1N
AGND18_TX1
TX0N
AVDD18_TX1
AGND18_TX2
AGND33_TX
AVDD33_TX
EXT_CAP
AVDD33_VPLL
EXT_RES
AGND33_VPLL
GPIO8_HPLG
GPIO7_DDC_CLK
DVDD18
GPIO6_DDC_DA
GPIO5
GPIO4
DVDD33
RA4
RA5
RA6
RA7
RA11
DVSS33
DVDD33
RA3
DVDD18
RA1
RA0
BA1
BA0
XRAS
XCAS
XRWE
DVDD33
GPIO20/SD_CMD
RD8
125
126
RD12
RD11
G
P
I
O
2
1
/
S
D
_
C
L
K
D
Q
M
0
G
P
I
O
2
2
/
S
D
D
0
/
I
N
T
123
124 RD13
RD14
U
P
3
_
5
/
T
X
D
U
P
3
_
4
/
R
X
D
U
P
3
_
1
U
P
3
_
0
U
P
1
_
7
/
S
D
A
U
P
1
_
6
/
S
C
L
U
P
1
_
5
/
V
S
D
A
U
P
1
_
4
/
V
S
T
B
U
P
1
_
3
/
V
S
C
K
U
P
1
_
2
/
G
P
I
O
1
9
NC
V
_
O
U
T
V
S
S
N
C
C
T
V
D
D
3.3 3.3 0
0
1
.
8
V
3
.
3
V
1.9
NC
3
.
3
3
.
3
3
.
3
3
.
2
3
.
2
3
.
1
3
.
2
3
.
3 0
3
.
2
2
.
9
2
.
0
3
.
0
3
.
3
0
.
2
1
.
0
0
.
8
0
.
7
1
.
1
1
.
3
1
.
0
1
.
1
1
.
3
1
.
0
1
.
0
1
.
3
1
.
0
1
.
3
1
.
1
1
.
1
F
S
DADVSSB
00
0.5
3.3
0.7
0.4
3.3
0.4
0.7
0.7
1.0
1.0
1.9
1.1
1.0
1.1
1.1
1.0
1.0
3.2
3.2
1.3
0.1
5.0
1.8
5.0
0.3
3.3
1.6
1.6
1.6
1.5
0.1
0.1
0
0
3.3
1.6
3.3
1.5
2.1
1.8
1.8
0.6
0.1
1.4
2.7
3.1
2.9
3.1
2.0
1
.
0
1
.
6
0 0 0 1
.
3
3
.
3
1
.
7
1
.
9
0 0 0 0 3
.
3
3
.
3
3
.
3
0 0 2
.
9
0 3
.
3
0 3
.
3
0 3
.
3
1
.
1
3
.
3
1
.
2
2.9
1.1
3.3
0
0
0
1.8
0
0
0
0
0
0
0
3
2
DVD MT PCB ASSY (1/7)
(A2L502A130)
48 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
SH4001
YQ-12
IC4005 M12L64164A-5TG
64Mbit(4M*16) 166MHz SDRAM
2
8
2
9
3
0
3
1
3
2
3
3
3
4
3
5
3
6
3
7
3
8
3
9
4
0
4
1
4
2
4
3
4
4
4
5
4
6
4
7
4
8
4
9
5
0
5
1
5
2
5
3
5
4
IC4004 ES29LV160EB-70TG
16Mbit FLASH IC
1
1
0
1
1
1
2
1
3
1
4
1
5
1
6
1
7
1
8
1
9
2
2
0
2
1
2
2
2
3
2
4
2
5
2
6
2
7
2
8
2
9
3
3
0
3
1
3
2
3
3
3
4
3
5
3
6
3
7
3
8
3
9
4
4
0
4
1
4
2
4
3
4
4
4
5
4
6
4
7
4
8
5
6
7
8
9
R4044
10K
C
4
1
2
0
0
.
1
B
C4102
0.1 B
C4101
0.1 B
C4062
0.001 B
C4040
1 B
C
4
0
5
0
1
0
0
0
6
.
3
V
Y
K
_
P
DURING PLAYBACK.
MEASURED WITH THE D
NOTE:THE DC VOLTAGE EACH P
DQ0
DQ1
DQ2
DQ3
DQ4
DQ15
A17 A16
DQ5
DQ6
DQ7
A15
DQ8
DQ9
DQ10
DQ14
A14
DQ11
DQ12
DQ13
DQ13
A0 A13
DQ14
DQ15
MA0
AD7 A12
MA1
MA2
MA3
DQ12
A11
MA4
MA5
MA6
DQ11
AD6 A10
MA7
MA8
MA9
A9
MA10
MA11
DWE#
DQ10
AD5 A20
SDCKE
DQM1
DQM0
DQ9
DCAS#
DRAS#
DBA1
AD4 PWR#
DBA0
SDCLK
DCS#
DQ8
A0
A1
A2
A3
A4
A5
AD3
A6
A7
A8
DQM1
A9
A10
A11
SDCLK
AD2 A19
A12
A13
A14
SDCKE
A18
A15
A16
A17
AD1 A8
A18
A19
A20
MA11
A7
AD0
AD1
AD2
MA9
AD0 A6
AD3
AD4
AD5
MA8
PRD# A5
AD6
AD7
PRD#
MA7
A4
PCE#
PWR#
USB_P_ON-L
MA6
PCE# A3
USB_FLAG
USBN
USBP
MA5
A1 A2
USB_GND
IR
FP_DO
MA4
STB
FP_DI
FP_SCK
V+3D
V+3
FLDC-
-28V
FLDC+
V+3E
D_GND
V+5V_USB
MEMORY/USB SCHEMATIC DIAG
FROM/TO POWER PORT
FROM/TO MPEG/MICON/DSP
NC
VSS
DQ15
VSSQ
DQ12
DQ11
V
VD
V
VSSQ
DQ10
DQ9
VDDQ
DQ8
LD
VSS
UDQM
CLK
CKE
NC
A9
A11
A10
V VSS
A4
A5
A6
A7
A8
NC/RFU NC
NC
0.0
1.7
1.7
1.7
1.7
1.7
1.7
1.7
1.9
1.7
1.9
0.0
1.5
3.3
1.5
1.5
0.0
1.5
1.5
3.3
1.5
1.5
0.0
1.5
0.0
DQ13
VDDQ
DQ14
W
C
R
BA0/
BA1/
V
VD
V
0
0
1.4
2.6
2.6
1.4
1.2
1.6
1.6
3.3
1.3
0.9
1.6
2.5
1.5
1.6
1.3
2.5
1.5
0.8
1.0
1.7
1.6
0.8
0
0.7
0.6
1.2
1.3
1.9
0.7
1.2
A16
VSS
VSS
CE#
A0
A15
A14
A13
A12
A11
A9
A8
A10
A19
D7
D14
D6
D13
D5
D12
D4
VCC
D11
D3
D10
D2
D9
D1
D8
D0
NC
NC
NC
NC
NC
NC
NC
OE#
RESET#
RY/BY#
0
D15/A1
NC (WP#/ACC)
0
0.1
0
0
3.3
A7
A6
A5
A4
A3
A2
A1
A18
A17
0.1
1.6
0.7
1.4
1.6
1.3
1.6
1.7
2.5
1.6
NC
NC
NC
NC
WE#
NC
BYTE#
49 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
CAUTION: DIGITAL TRANSISTOR
IC4005 M12L64164A-5TG
64Mbit(4M*16) 166MHz SDRAM IC
1
1
0
1
1
1
2
1
3
1
4
1
5
1
6
1
7
1
8
1
9
2
2
0
2
1
2
2
2
3
2
4
2
5
2
6
2
7
2
8
2
9
3
3
0
3
1
3
2
3
3
3
4
3
5
3
6
3
7
3
8
3
9
4
4
0
4
1
4
2
4
3
4
4
4
5
4
6
4
7
4
8
4
9
5
5
0
5
1
5
2
5
3
5
4
6
7
8
9
Q4003
KRC103SRTK
USB_P_ON-H
D4005
EC31QS04
(SCHOTTKY 3.0A)
CP4004
A2001WV2-4P
1
2
3
4
L4001
DLP11SN201HL2L
1
2 3
4
CP4002
00_6232_011_006_800+
1
10
11
2
3
4
5
6
7
8
9
D4003
AVRL161A1R1NT
D4002
AVRL161A1R1NT
R4021
10K
R
4
0
1
0
1
0
0
K
R
4
0
0
7
1
0
K
R
4
0
4
8
2
2
K
TP4050
TP4035
W844
W
8
3
7
W
8
4
8
C
4
1
3
3
1
0
0
P
C
H
C
4
1
3
4
3
3
P
C
H
C
4
1
3
5
1
0
0
P
C
H
C
4
1
3
2
3
3
P
C
H
C
4
1
1
5
1
B
0
.
1
B
C4123
0.1 B
C4052
0.1 B
C
4
0
7
6
0
.
1
B
C
4
1
2
2
1
0
0
P
C
H
C
4
1
1
4
1
B
C
4
0
7
7
0
.
1
B
C
4
1
4
3
0
.
0
0
1
B
C
4
1
4
2
1
0
0
1
0
V
Y
K
_
P
C
4
0
7
8
1
0
2
5
V
K
A
_
P
IC4007
R5523N001B-TR-F
HIGH SIDE SW IC
1
2
3 4
5
DURING PLAYBACK.
:THE DC VOLTAGE EACH PART WAS
DQ7
DQ6
DQ5
DQ4
DQ3
V+3
V+5V_USB
DQ2
DQ1
USB_FLAG
DQ0
USB_P_ON-L
DQM0
DWE#
DCAS#
DRAS#
DCS#
FLDC-
DBA0 -28V
FLDC+
DBA1 D_GND
MA10 V+3E
IR
MA0 FP_DO
STB
MA1 FP_DI
FP_SCK
MA2
MA3
USBN
USBP
USB+5V
ATIC DIAGRAM
0
0
3.3
PCB130
DMG100
FROM/TO DISPLAY
VSS
DQ0
DQ1
DQ2
DQ15
VSSQ
DQ12
DQ11
VSSQ
DQ3
DQ4
VDDQ
DQ5
DQ6
VSSQ
DQ7
VSSQ
DQ10
DQ9
VDDQ
DQ8
LDQM
VSS
UDQM
CLK
CKE
NC
A9
A11
A10/AP
A0
A2
A1
A3
VDD VSS
A4
A5
A6
A7
A8
NC/RFU
3.3
1.5
3.3
1.5
1.5
0.0
1.5
1.5
3.3
1.5
1.5
0.0
1.5
3.3
2.0
3.3
3.3
3.3
3.3
3.3
1.0
0.0
1.7
1.7
1.7
1.7
3.3
DQ13
VDDQ
DQ14
WE#
CAS#
RAS#
CS#
BA0/A13
BA1/A12
VDD
VDDQ
VDD
EN
GND
/FLG VIN
VOUT
5.3
5.3
0
3.3
3.3
DGND
FLDC+
-28V
FLDC-
V+3E
IR
STB
DO (F to M)
DI (M to F)
CLK
DGND
USBN
USBP
USB+5V
GND(USB)
(A2L502A130)
W810
W806
W805
50 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
DANS LA NOMENCLATURE DES PIECES.
DANGEREUSES AN POINT DE VUE SECURITE
:LES PIECES REPAREES PAR UN ETANT
ATTENTION
:SINCE THESE PARTS MARKED BY
CAUTION
ARE
CP2301
LD07T2-24ND-03
PICK-UP(GOLD)
1
10
11
12
13
14
15
16
17
18
19
2
20
21
22
23
24
3
4
5
6
7
8
9
CP2302
00_6232_005_006_800+
LOADING
1
2
3
4
5
CP2303
00_6232_006_006_800+
SLED/SPINDLE
1
2
3
4
5
6
Q
2
3
0
6
U
M
6
K
1
N
V
R

C
T
L
1 2 3
4 5 6
R2309
10K
R2316
3.3K
R2312
8.2K +-1
R2325
470 +-1
R2313
10K +-1%
R2329_1
1 1/4W
(2125)
R
2
3
3
8
1
0
K
R
2
3
4
2
6
8
0
K
R2310
10K
R2307
100K
R
2
3
0
8
1
0
K
R2306
100K
R2304
10K
R
2
3
1
9
1
5
0
K
R
2
3
3
1
1
5
0
K
JG2304
JG2305
JG2306
JG2309
JG2310
JG2311
JG2312
JG2313
JG2314
JG2315
JG2316
JG2317
JG2318
JG2319
JG2308
JG2307
JG2320
JG2321
JG2322
JG2323
JG2302
TP2324
TP2325
TP2326
TP2327
TP2328
JG2303
TP2330
TP2333
W802
C2301 0.1 B
C2302
0.1 B
C2303 0.1 B
C2323
0.1 B
C
2
3
2
2
0
.
0
0
2
2
B
C2311
0.1 B
C2307
0.1 B
C2304 100 16V KA_P
C2306
100 10V
YK_P
Q2301
KTC3875S_Y_RTK
VCR_CTL
DURIN
MEASU
NOTE:THE DC
I
O
A
V
+
5
S
V+5S
F
V20
E
D
C
IOA
RF
B
A
MDI1
T+
T-
F+
F-
LOAD-
F
M
S
O
T
R
S
O
S
T
B
Y
LOAD+
V+6A
TROUT
TRIN
OPO
OP-
OP+
LIMIT
MOT_SLED-
MOT_SLED+
MOT_SPDL+
MOT_SPDL-
V+3F
M
O
T
_
S
L
E
D
+
M
O
T
_
S
L
E
D
-
T
-
T
+
LOADER/MOTOR DR
5.0
0.0
0.0
LOAD+
LOAD-
GND
OPEN
CLOSE
NC
SW(GND)
LIMIT SW
SLD-
SLD+
SPD-
SPD+
VRCOM
TRKG DRV
TRKG RTN
FOCS RTN
FOCS DRV
VCC
D
B
VR780(CD)
VRF(RF_OUT)
SW1(DVD/CD)
C
E
VS
F
GND
A
VR650(DVD)
GND
GND
LD_DVD(650)
LD_CD(780)
PD/GND
NC
Track
Sled
0.0 0.0 0.0
0.2 4.9 0.0
1
S
1
D
1
G
2
D
2
S
2
G
51 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
Q2304
KTA1504S_Y_RTK
LD DRIV for CD
Q2305
KTA1504S_Y_RTK
LD DRIV for DVD
Q2302
KTA1504S_Y_RTK
LD DRIV for CD
Q2303
KTA1504S_Y_RTK
LD DRIV for DVD
IC2301 AM5766
MOTOR DRIVER IC
1
1
0
1
1
1
2
1
3
1
4
1
5
1
6
1
7
1
8
1
9
2
2
0
2
1
2
2
2
3
2
4
2
5
2
6
2
7
2
8
2
9
3
3
0
4
5
6
7
8
9
R2309
10K
R2316
3.3K
R2312
8.2K +-1%
R2325
470 +-1%
R2313
10K +-1%
R2317
8.2K +-1%
R2311
18K +-1%
R2310
10K
R2304
10K
R2318
10K
R2327
10K
TP2332
TP2301
TP2331
TP2329
JG2329
TP2342 JG2330
TP2341
JG2301
W802
C2325_1
100P CH
C2312
0.1 B
C2311
0.1 B
C2307
0.1 B
C2308
0.01 B
C2305
0.1 B
C
2
3
2
0
1
0
0
1
0
V
Y
K
_
P
C
2
3
2
1
1
0
0
1
0
V
Y
K
_
P
NR2301
4D03WGJ04R7T5E
DURING PLAYBACK.
I
O
A
V20
A
B
C
D
V+3F
E
F
MDI1
LDO2
LDO1
IOA
LDO1
V1P4
LIMIT
TROUT
TRIN
STBY
DMSO
FMSO
TRCLOSE
TROPEN
TRSO
FOSO
LDO2
OPO
OP+
OP-
RF
V+3F
V+5S
V+6A
D_GND
M_GND
V
1
P
4
F
O
S
O
D
M
S
O
T
R
O
P
E
N
T
R
C
L
O
S
E
M
O
T
_
S
P
D
L
-
M
O
T
_
S
P
D
L
+
L
O
A
D
+
L
O
A
D
-
F
+
F
-
FROM POWER PORT
MOTOR DRIVE SCHEMATIC DIAGRAM
PCB130
DMG100
.0
N
C
2.03
3.5
13.2
13.2
0
0
1.38
2.92
2.81
2.88
2.82
5.56
3.24
13.2
5.77
N
C
N
C
N
C
N
C
3.34
5.6
N
C
2.77
2.91
1.69
3.25
3.26
3.22
5.76
0
3.51
1.46
1.27
13.13
13.13
Vcc1
VOTR-
VOTR+
VOSL+
VOSL-
VOFC-
VOFC+
REGO 1
VINSL+
REGO 2
TRB_1
VINFC
REV
FWD
VOTK-
VOTK+
VOLD+
VOLD-
VCTL
Vcc2
GND
VINLD
TRB_2
VINTK
BIAS
MUTE
PGND PGND
OPOUT
OPIN
3.3
0
3.3
0
3.3
3.3
3.1
2.5 2.5
3.1
2.0 2.0
(A2L502A130)
52 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
I
C
8
0
0
3
P
C
M
1
7
4
2
K
E
/
2
K
A
U
D
I
O

D
A
C

(
L
,
R
)

I
C
1
10 11 12 13 14 15 16
2 3 4 5 6 7 8
9
I
C
8
0
0
5
P
C
M
1
7
4
2
K
E
/
2
K
A
U
D
I
O

D
A
C

(
L
s
,
R
s
)

I
C
1
10 11 12 13 14 15 16
2 3 4 5 6 7 8
9
I
C
8
0
0
4
P
C
M
1
7
4
2
K
E
/
2
K
A
U
D
I
O

D
A
C

(
C
,
L
f
e
)

I
C
1
10 11 12 13 14 15 16
2 3 4 5 6 7 8
9
D
8
0
0
3
U
D
Z
S
N
P
6
.
8
B
CP8001A2001WV-2A
(CU223002)
1
2
Q
8
0
0
3
R
N
1
9
0
7
(
T
5
L
_
F
_
T
)
M
U
T
E

C
T
L
1 2 3
4 5 6
Q
8
0
0
2
R
N
1
9
0
7
(
T
5
L
_
F
_
T
)
M
U
T
E

C
T
L
1 2 3
4 5 6
Q
8
0
0
4
R
N
1
9
0
7
(
T
5
L
_
F
_
T
)
M
U
T
E

C
T
L 1 2 3
4 5 6
Q8001
KTA1505S-Y-RTK/P
P.CON+3.3V
Q8013
KTA1504S_Y_RTK
MUTE CTL
Q8014
KTA1504S_Y_RTK
MUTE CTL
Q8012
KTA1504S_Y_RTK
MUTE CTL
Q8020
KRC103SRTK
MUTE CTL
D8004
MA111
D8005
MA111
D8006
MA111
R80
10K
R8003
100
R8024 5.6K
R8035
10K +-1%
R
8
0
2
9
4
.
7
K
R8020 2.2K
R8002
100
R8001
100
R
8
0
4
9
6
8
0
K
R
8
0
5
4
6
8
0
K
R
8
0
6
5
2
2
K
R
8
0
2
6
5
.
6
K
R8019 2.2K
R
8
0
2
1
2
.
2
K
R8022
2.2K
R
8
0
0
9
1
K
R
8
0
0
5
1
0
K
R8008
10
R8007
10
R8006
10
R
8
0
1
2
2
2
K
R8018
10
R8017
10
R
8
0
2
7
4
.
7
K
R8036
10K +-1%
R8031
10K +-1%
R8033
10K +-1%
R804
10K +
R
8
0
2
5
6
8
0
K
R
8
0
2
8
4
.
7
K
R8038 6.8K
R8023 6.8K
TP8004
TP8011
TP8001
TP8002
TP8003
W879
W878
W
8
1
9
C8026
0.0022 CH
C8025
330P CH
C
8
0
3
4
0
.
1
B
C
8
0
0
4
1
B
C
8
0
4
9
1
B
C
8
0
5
2
1
B
C
8
0
5
4
1
B
C
8
0
3
7
0
.
1
B
C
8
0
1
5
0
.
1
B
C
8
0
1
4
0
.
1
B
C
8
0
3
0
1
B
C
8
0
3
9
1
B
C
8
0
1
9
1
B
C
8
0
0
2
1
B
C
8
0
1
7
1
B
C
8
0
1
3
0
.
0
0
1
B
C
8
0
3
6
0
.
1
B
C
8
0
4
4
C
8
0
4
5
C
8
0
7
3
C
8
0
4
3
C8023
CH
C
8
0
2
0
1
B
C8040
100 10V YK_P
C8032
100 10V YK_P
C
8
0
4
8
1
0
0
1
0
V
Y
K
_
P
C
8
0
5
0
C8035
100 10V YK_P
C
8
0
3
1
2
2
0
6
.
3
V
Y
K
_
P
C
8
0
2
8
2
2
0
6
.
3
V
Y
K
_
P
C
8
0
2
7
4
7
1
6
V
Y
K
_
P
C8041
100 10V YK_P
C
8
0
2
9
1
0
0
0
6
.
3
V
Y
K
_
P
C8033
100 10V YK_P
C
8
0
4
7
1
0
0
1
0
V
Y
K
_
P
C8072
100 10V YK_P
C
8
0
1
6
1
0
2
5
V
K
A
_
P
I
C
8
0
0
1
T
C
7
S
H
U
0
4
F
U
(
T
E
8
5
L
_
F
I
N
V
E
R
T
E
R

I
C
1 2 3
4 5
Q8009
KTC3875S_Y_RTK
REF GEN
Q8011
KTC3875S_Y_RTK
REF GEN
Q8010
KTC3875S_Y_RTK
REF GEN
Q8008
KTC3875S_Y_RTK
REF GEN
B8001
MMZ1608R102CT
DURING PLAYBACK.
OF PRINTING AND SUBJECT TO CHANGE WIT
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST A
V
+
1
2
A
T
XAMUTE
XMMUTE
SD
SCK
DAC_XCS0
ABCK
XMMUTE
ALRCK
SD
ACLK
ASPDIF
SCK
ASDAT0
DAC_XCS0
ASDAT1 ACLK1
ASDAT2
V+3A
V+12
V+12AT
V+5A
D_GND
ABCK1
ASDAT2
ALRCK
V+5A
V+3A3
V+12AT
XMMUTE
SD
V+3A SCK
DAC_XCS0
V+3A3
ACLK1
V+3A2
V+3A1
V+5A
AUDIO_L
AUDIO_R
GND
ABCK1
ASDAT1
ALRCK
V+5A
ABCK ABCK1
V+3A2
ABCK0
V+12AT
V+12
XAMUTE
SD
ACLK1
SCK
DAC_XCS0
ACLK0
ACLK
ABCK0
ASDAT0
ALRCK
V+5A
V+3A1
A
L
A
R
FROM MPEG/MICON/DSP
AUDIO/JACK SCHEMATIC DIAGRAM
0
0 2.6 2.6
0 0 0
0 0 0
0 1.6 3.2
Q
2
Q
1
0 0 0
0 1.6 3.2
FROM POWER PORT
TO VIDEO
Q
2
Q
1
(CP8102)
NC
C
S
S
C
K
Z
E
R
O
R
Z
E
R
O
A
V
C
O
M
G
N
D
_
A
P
C
M
M
C
K
Z
E
R
O
L
/
M
A
S
I
P
C
M
B
C
K
P
C
M
D
A
T
A
P
C
M
L
R
C
K
G
N
D
D
V
C
C
V
O
U
T
L
V
O
U
T
R
V
D
D
SPDIF
GND
G
N
D
_
A
V
C
O
M
Z
E
R
O
R
Z
E
R
O
A
Z
E
R
O
L
/
M
A
S
I
S
C
K
C
S
P
C
M
M
C
K
P
C
M
B
C
K
P
C
M
D
A
T
A
P
C
M
L
R
C
K
G
N
D
D
V
D
D
V
C
C
V
O
U
T
L
V
O
U
T
R
1.5 1.6
0.9
5.8
6.3
12.5
12.5
5.8
6.3
5.8
12.5
6.3
6.8
6.3 12.5
NC
0
3
.
3
4
.
9
2
.
5
2
.
4
2
.
4
3
.
1
3
.
1
0
0
0 0
1
.
6
1
.
6
1
.
5
1
.
5
0
3
.
3
4
.
8
2
.
4
0 2
.
4
3
.
2
0 0 3
.
2
3
.
2
1
.
6
NC
2
.
4
1
.
6
0
1
.
5
P
C
M
M
C
K
C
S
S
C
K
S
I
Z
E
R
O
L
/
M
A
Z
E
R
O
R
Z
E
R
O
A
V
C
O
M
G
N
D
_
A
V
O
U
T
R
V
O
U
T
L
V
C
C
V
D
D
G
N
D
D
P
C
M
L
R
C
K
P
C
M
D
A
T
A
P
C
M
B
C
K
NC
1
.
5
0
3
.
3
4
.
8
2
.
4
2
.
4
0 2
.
4
3
.
2
0 0 3
.
2
3
.
2
1
.
6
1
.
6
0
0
0
3.3 3.3
2.7
NC
1.5 0 0
1.6 3.3
GND
VCC
1.5 1.6
0.9
VREF_F
VREF_S
VREF_C
0 0
Q
2
Q
1
5.0
0.0022
53 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
H1 H2
E
H1 H2
E
J8002
RCA-405A(CUSN)-06
LS/RS/C/LFE
1
2 3
4
5 6
H1 H2
E
J8001
RCA-207B(CUSN)-02
L/R
1
2 3
R8041
10K +-1%
R
8
0
7
0
2
2
K
R8096
220 +-1%
R8052
10K +-1%
R8048
18K +-1%
R8092
220 +-1%
R
8
0
6
9
2
2
K
R8053
10K +-1%
R8035
10K +-1%
R8046
10K +-1%
R8045
18K +-1%
R
8
0
4
9
6
8
0
K
R
8
0
5
4
6
8
0
K
R8055
18K +-1%
R8061
10K +-1%
R8059
18K +-1%
R
8
0
6
5
2
2
K
R8071
220 +-1%
R8094
220 +-1%
R8078
220 +-1%
R8095
220 +-1%
R8050
18K +-1%
R8058
10K+-1%
R8076
220 +-1%
R8093
220 +-1%
R8036
10K +-1%
R8031
10K +-1%
R8033
10K +-1%
R8043
10K +-1%
R
8
0
6
8
2
2
K
R8072
220 +-1%
R8063
10K +-1%
R8064
18K +-1%
R
8
0
6
7
2
2
K
R8073
1K
R8074
1K
R8077
1K
R8079
1K
R8099
220 +-1%
R8087
220 +-1%
R8088
1K
R8090
1K
R8091
1K
R8080
220 +-1%
R8085
1K
R8082
220 +-1%
R8081
220 +-1%
R
8
0
6
6
2
2
K
R
8
0
7
5
2
2
K
TP8019
TP8017
TP8013
TP8015
TP8014
TP8012
W
8
6
8
C
8
0
6
7
0
.
1
B
C
8
0
5
7
1
0
0
P
C
H
C
8
0
4
9
1
B
C
8
0
5
2
1
B
C
8
0
4
6
5
6
0
P
C
H
C
8
0
5
4
1
B
C
8
0
5
9
1
0
0
P
C
H
C
8
0
4
4
5
6
0
P
C
H
C
8
0
6
4
0
.
1
B
C
8
0
4
5
5
6
0
P
C
H
C
8
0
5
6
1
0
0
P
C
H
C
8
0
5
1
5
6
0
P
C
H
C
8
0
5
3
1
0
0
P
C
H
C
8
0
7
3
5
6
0
P
C
H
C
8
0
6
3
0
.
1
B
C
8
0
4
3
5
6
0
P
C
H
C
8
0
0
9
3
3
0
P
C
H
C
8
0
6
2
1
0
0
P
C
H
C
8
0
5
5
1
0
0
P
C
H
C
8
0
1
0
3
3
0
P
C
H
C
8
0
0
7
3
3
0
P
C
H
C
8
0
0
6
3
3
0
P
C
H
C
8
0
0
5
3
3
0
P
C
H
C
8
0
0
8
3
3
0
P
C
H
I
C
8
0
0
7
R
C
4
5
8
0
I
D
R
A
U
D
I
O

L
P
F
&
A
M
P

I
C
1 2 3 4
5 6 7 8
I
C
8
0
0
2
R
C
4
5
8
0
I
D
R
A
U
D
I
O

L
P
F
&
A
M
P

I
C 1 2 3 4
5 6 7 8
I
C
8
0
0
8
R
C
4
5
8
0
I
D
R
A
U
D
I
O

L
P
F
&
A
M
P

I
C
1 2 3 4
5 6 7 8
C8040
100 10V YK_P
C8066
47 16V YK_P
C8061
47 16V YK_P
C8060
47 16V YK_P
C8065
47 16V YK_P
C
8
0
4
8
1
0
0
1
0
V
Y
K
_
P
C
8
0
5
0
1
0
0
1
0
V
Y
K
_
P
C8041
100 10V YK_P
C
8
0
4
7
1
0
0
1
0
V
Y
K
_
P
C
8
0
6
8
4
7
1
6
V
Y
K
_
P
C8069
47 16V YK_P
C8058
47 16V YK_P
TK
Q8016
2SD1306NE
MUTE SW
Q8015
2SD1306NE
MUTE SW
Q8017
2SD1306NE
MUTE SW
Q8018
2SD1306NE
MUTE SW
Q8021
2SD1306NE
MUTE SW
Q8023
2SD1306NE
MUTE SW
Q8019
2SD1306NE
MUTE SW
Q8024
2SD1306NE
MUTE SW
D SUBJECT TO CHANGE WITHOUT NOTICE.
DIAGRAM IS THE LATEST AT THE TIME
V
+
1
2
C
O
A
X
I
A
L
C
E
N
T
E
R
S
L
S
R
L
F
E
A
U
D
I
O
_
R
A
U
D
I
O
_
L
A
L
A
R
L R
PCB130
DMG100
SL SR C LFE
5
.
7
5
.
7
5
.
7
0
+
-
-
+
+
V
S
-
V
S
5
.
7
5
.
7
1
2
.
2
5
.
7
+
-
-
+
+
V
S
-
V
S
5
.
7
5
.
7
5
.
7
5
.
7
5
.
7
5
.
7
1
2
.
2
0
+
-
-
+
+
V
S
-
V
S
0 5
.
7
5
.
7
5
.
7
1
2
.
2
5
.
7
5
.
7
5
.
7
0
0.6
0
0
0.6
0
0.6
0
0
0
0
0.6
0
0
-0.7
0
0
-0.7
0
0
-0.7
0
-0.7
0
(A2L502A130)
8
5
6
9
10
7
W
8
7
0
54 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
IC7301 LA73054
VIDEO DRIVER 6CH IC
1
1
0
1
1
1
2
1
3
1
4
1
5
1
6
1
7
1
8
1
9
2
2
0
2
1
2
2
2
3
2
4
2
5
2
6
2
7
2
8
2
9
3
3
0
3
1
3
2
3
3
3
4
3
5
3
6
4
5
6
7
8
9
Q7302
KRC103SRTK
P-H/I-L
R7315
1K
TP7303
TP7302
W877
W889
C7309
1 B
C7313
0.1 B
C7302
0.1 B
C7317
0.1 B
C7305
1 B
C7308
1 B
C7307
1 B
C7306
1 B
C7304
0.1 B
C
7
3
1
9
1
0
0
1
0
V
Y
K
_
P
C7312
100 10V YK_P
DURING PLAYBACK.
OF PRINTING AND
NOTE:THIS SCHEMATIC D
CVBS
SQUEEZE
LETTER
AUDIO_L
S_C
AUDIO_R
S_Y
SQUEEZE
VSEL1
LETTER
CVBS
S_C
VSEL1
S_Y
G/Y
G/Y
B/CB
R/CR
I/XP
B/CB
R/CR
I/XP
P-H/I-L
V+5
D_GND
V+6A
V
S
E
L
1
FROM AUDIO/JACK
VIDEO SCHEMATIC DIAGRAM
FROM POWER PORT
1.2
0
2.8
0
0
5
2.9
0
0
0
2
0
0
2
5
0
0
0
2.5
2.4
2.5
0
2.8
5
0
2.6
0
0
2.7
0
2.8
0
0
0
2.7
5
0
(1D=H,2D=L)
(1D=H,2D=L)
DRIVE2
(ON=H,OFF=L)
(ON=H,OFF=L)
(9dB=H,6dB=L)
(P=H,I=L)
(RGB=H,YUV=L)
(MIX=H,OFF=L)
(9dB=H,6dB=L)
LPF
IN SW
AMP1
DRIVE1
VCC21
CVBS out
GND21
C out
C-DC out
GND22
Y1 out
GND23
GND24
Y2 out
VCC22
CB out
GND25
CR out
GND26
REG
GND12
CR in
AMP2
CB in
MUTE2
Y2 in
YC-MIX
Y1 in
GND11
C in
LE
SQ
MUTE1
CVBS in
VCC1
3.4
0
55 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
CP7301
IMSA-9604S-12C
VIDEO/AUDIO for 21PIN
1
10
11
12
2
3
4
5
6
7
8
9
J7304
DIN-409A
S-VIDEO OUT for HE
1 2
3 4
5 6
IC7302
SN74CBT3257PWR
4CH BUS SW IC
1
1
0
1
1
1
2
1
3
1
4
1
5
1
6
2
3
4
5
6
7
8 9
H1 H2
E
H1 H2
E
J7302
RCA-405A(CUSN)-08
CVBS/Y/U/V
1
2 3
4
5 6
D
7
3
1
2
M
A
1
1
1
D
7
3
0
9
M
A
1
1
1
D
7
3
1
1
M
A
1
1
1
D
7
3
0
8
M
A
1
1
1
D
7
3
1
0
M
A
1
1
1
D
7
3
0
7
M
A
1
1
1
R
7
3
0
1
1
0
K
R
7
3
1
7
7
5 1
/
1
0
W
+
-
1
%
R
7
3
1
6
7
5 1
/
1
0
W
+
-
1
%
R
7
3
1
9
1
.
2
K
R
7
3
2
1
1
.
2
K
R
7
3
0
5
7
5
1
/
1
0
W
+
-
1
%
R
7
3
0
4
7
5
1
/
1
0
W
+
-
1
%
R
7
3
2
0
1
.
2
K
R
7
3
0
2
7
5
1
/
1
0
W
+
-
1
%
R
7
3
0
3
7
5
1
/
1
0
W
+
-
1
%
TP7301
C
7
3
3
0
0
.
1
B
C
7
3
2
2
0
.
0
0
1
B
C
7
3
2
9
4
7
0
6
.
3
V
Y
K
_
P
C
7
3
1
8
1
0
0
0
6
.
3
V
Y
K
_
P
C
7
3
1
6
1
0
0
0
6
.
3
V
Y
K
_
P
C
7
3
1
4
4
7
0
6
.
3
V
Y
K
_
P
C
7
3
1
5
4
7
0
6
.
3
V
Y
K
_
P
B
7
3
0
1
B
L
M
1
8
B
D
1
0
2
S
N
1
B
7
3
0
2
B
L
M
1
8
B
D
1
0
2
S
N
1
B
7
3
0
4
B
L
M
1
8
B
D
1
0
2
S
N
1
B
7
3
0
5
B
L
M
1
8
B
D
1
0
2
S
N
1
V
S
E
L
1
A
U
D
I
O
_
R
A
U
D
I
O
_
L
S
Q
U
E
E
Z
E
21PIN-G/D-Y
21PIN-B/D-U
21PIN-R/D-V
P-H/I-L_RGB-H
ASP/FS
(CP503)
PCB130
DMG100
C
V
B
S
V U Y
RGB-H
R
B
G
GND
CVBS
AUDIO R
GND
AUDIO L
FS
GND
GND
C Y
ASP
S_Y
S_C
CVBS
3.3 3.3
1.8
2.4
2.6
1.3
2.5
2.5
2.4
2.4
1.3
5.0
0
0
GND
VCC
2B1
2B2
2A
1B2
1A
4B1
4B2
4A
3B1
3B2
3A
/OE
1B1
S
NC
NC
NC
FROM/TO POWER
(A2L502A130)
11
12
16 15
13
14
56 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
W855
W856
W861
N
V+3D
V+5H
TX2+
TX2-
TX1+
TX1-
TX0+
TX0-
TXC+
TXC-
HPD
HDMI_SCL
HDMI_SDA
D_GND
A_GND
A_GND
HDMI SCHEMATIC DIAGRAM
W863
W865
57 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
CP5901
E110001-11
HDMI CONNECTOR
1
10
11
12
13
14
15
16
17
18
19
2
3
4
5
6
7
8
9
L5902
EXC28CG900U
1
2
3
4 5
6
7
8
L5901
EXC28CG900U
1
2
3
4 5
6
7
8
Q
5
9
0
6
U
M
6
K
1
N
S
W
1 2 3
4 5 6
R
5
9
1
9
1
.
5
K
R
5
9
2
0
1
.
5
K
W862
W864
W840
C
5
9
2
1
1
0
(
2
1
2
5
)
B
C5901
0.01 B
C
5
9
2
5
1
0
0
P
C
H
C
5
9
2
0
0
.
1
B
B5901
S D
G
Q5902
2SK3019_TL
SW
DURING PLAYBACK.
TX2+
TX2-
TX1+
TX1-
TX0+
TX0-
TXC+
TXC-
V+5H
HDMI_SCL
HDMI_SDA
HPD
V+3D
4.89 5.06 4.82
5.07 4.89 4.82
PCB130
DMG100
0 0
3.4
NC
TX2+
TX1+
TX1-
TX0+
TX0-
TXC-
TXC+
D2+
D2-S
D2-
D1+
D1-S
D0+
D0-S
D0-
CLK-S
CLK-
CEC
SCL
SDA
GND
POWER
HOTPLUG
NC
D1-
CLK+
TX2-
1
S
1
D
1
G
2
D
2
S
2
G
(A2L502A130)
W853
C5907
10P CH
58 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
ATTENTION
CAUTION
ARE
C
4
0
9
5
4
7
6
.
3
V
K
A
_
P
IC4006
LD1117AL-ADJ-AA3-A-R
REG+1.8V IC
1 2 3
CP4003_1
A2001WV2-16P
1
10
11
12
13
14
15
16
2
3
4
5
6
7
8
9
R
4
0
1
3
3
9
+
-
1
%
R4012
68+-1%
R4011
12
TP4064
W843
W845
C
4
0
9
9
C
4
0
9
8
1
B
C
4
0
9
3
1
B
C
4
0
8
6
1
B
C
4
1
1
2
0
.
0
0
1
B
C
4
0
9
4
0
.
1
B
C
4
0
9
6
1
B
DUR
MEA
NOTE:THE
POWER PORT SCHEMATIC DIAGRAM
FROM/TO POWER
(CP502)
USB+5V
GND(UUSB)
ADJ VIN VOUT
1.8 0.6 3.3
GND
P.CON+5V
FL DC-
FL DC+
AT+3.3V
P.CON+12V
GND(M)
GND(D)
P.CON+6V
AT+3.3V
-28V
P.ON-H
GND
AT+12V for MUTE
59 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
6
3-A-R
1
IC5902 PQ1K503M2ZPH
HDMI+5V REG(300mA) IC
1
2
3 4
5
6
IC4009
BA00BC0WFP
13
V+5USB REG(1.3W/1A) IC
1 2 4 5 6
3
9
+
-
1
%
R
5
9
2
1
2
2
K
R
5
9
0
1
1
0
K
R4072
15K
+-1%
R4063
10K
R4073
220
R
4
0
7
4
4
.
7
K
+
-
1
%
R4058
100
R
4
0
2
8
1
0
K
TP4038
W822
W821
W842
W826
W832
W841
W839
W849
C
4
0
9
9
0
.
0
0
1
B
C
4
0
9
8
1
B
C
5
9
2
4
0
.
1
B
C
5
9
2
2
1
B
C
5
9
2
3
0
.
0
1
B
C4119
100PCH
C
4
1
4
0
0
.
0
0
1
B
C
4
0
9
6
1
B
C
4
0
5
6
0
.
0
1
B
C
4
1
4
1
1
0
0
1
0
V
Y
K
_
P
C
4
1
3
7
1
0
2
5
V
K
A
_
P
C
4
1
0
0
4
7
0
6
.
3
V
Y
K
_
P
B4001
B4002
DURING PLAYBACK.
V+3A
V+5A
V+5A
V+12AT
V+12AT
V+12
V+12
D_GND
V+5
V+5
V+6A
V+6A
V+6A
V+5S
V+5S
V+3F
V+3F
M_GND
D_GND
V+5H
V+5H
V+3H
V+3H
DVDD18
DVDD18
V+1R8
ADAC_GND
PWDN#
V+3
V+3
V+3E
V+1R8
V+3
V+3E
FLDC-
FLDC+
-28V
D_GND
V+5V_USB
FROM/TO MEMORY/USB
TO VIDEO
(VIDEO/OPT/COAX)
TO AUDIO/JACK
(MPEG/SDRAM/FLASH/RESET)
PCB130
DMG100
TO HDMI
TO LOADER/MOTOR DRIVE
(MOTOR)
(OPU)
(F/E)
(AUDIO AMP)
(AUDIO MUTE)
(AUDIO DAC)
VOUT
GND
NR ON/OFF
GND
VIN
5.8
0
5.4
5
0
1.2
(CORE)
DJ
(HDMI)
(HDMI)
0
V_C V_ADJ V_OUT GND V_IN
6.0 1.3 4.7 5.3
(FIP/LED/IR)
(A2L502A130)
C
5
9
0
6
0
.
0
1
B
60 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
10.8 OPERATION PCB ASSY
IC651
PT6315
FIP DRIVER IC
1
1
0
1
1
12 13 14 15 16 17 18 19
2
20 21 22
2
3
2
4
2
5
2
6
2
7
2
8
2
9
3
3
0
3
1
3
2
3
3
34 35 36 37 38 39
4
40 41 42 43 44
5
6
7
8
9
SW663
EVQ11L05R
PLAY
SW662
EVQ11L05R
+SKIP
SW660
EVQ11L05R
STOP
SW667
EVQ11L05R
POWER
SW653
EVQ11L05R
ENTER
SW654
EVQ11L05R
RIGHT
SW657
EVQ11L05R
UP
SW659
EVQ11L05R
LEFT
SW661
EVQ11L05R
HOMEMENU
SW666
EVQ11L05R
EJECT
SW665
EVQ11L05R
PAUSE
SW664
EVQ11L05R
-SKIP
SW652
EVQ11L05R
DOWN
SW658
EVQ11L05R
TOPMENU
SW656
EVQ11L05R
MENU
SW655
EVQ11L05R
RETURN
V651 HNV-08SS84
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 31 32
Vout
B+
GND
OS651
KSM-2001TC2P
1
2
3
D
6
6
0
L
T
L
-
1
C
H
E
E
-
0
0
2
A
H
D
M
I

L
E
D
(
R
E
D
)
C
P
6
0
3
B
2
0
1
3
H
0
2
-
3
P
1 2 3
C
P
6
0
4
B
2
0
1
3
H
0
2
-
3
P
1 2 3
D652 1SS133
D651 1SS133
D655 1SS133
D654 1SS133
D657 1SS133
D656 1SS133
D659 1SS133
D658 1SS133
R666
47 1/4W
R
6
6
4
3
3
0
1
/
4
W
T
P
6
6
2
C
6
5
1
0
.
1
B
C
6
7
5
1
B
C
6
7
6
C
6
5
8
C
6
5
3 4
7
6
.
3
V
K
A
_
P
C
6
7
4
4
7
6
.
3
V
K
A
_
P
DURING PLAYBACK.
OF PRINTING AND SU
NOTE:THIS SCHEMATIC DIA
IR
V+3E
P
1
6
P
1
5
P
1
4
P
1
3
P
1
2
P
1
1
P
1
0
P
9
P
8
P
7
P
6
P
5
P
4
P
3
P
2
P
1
G
R
8
G
R
7
SW2
SW1
P
8
P
9
P
1
0
P
1
1
P
1
2
P
1
3
P
1
4
P
1
5
P
1
6
P7
P6
P5
P4
P3
P2
P1
G
R
8
G
R
7
G
R
6
G
R
5
G
R
4
G
R
3
G
R
2
G
R
1
L
E
D
I
R
V
+
3
E
G
N
D
SW1
SW2
PCB271
DISPLAY SCHEMATIC DIAGRAM
N
C
N
C
STB
12
V
D
D
23
-12.0
-6.0
-18.0
0 -19.0 -15.6 -19.0 -9.5 -13.0 -9.5 -12.6 -13.0 -6.0
LED1
LED2
LED4
CLK
34
V
D
D
44
NC
NC
NC
-18.0
-18.0
-18.0
-18.0
-18.0
-18.0
-18.0
-18.0
-16.0 -16.0 -16.0 -16.0 -16.0 0
K2
K1
DI
DO
OSC
GND
P
1
6
P
1
5
P
1
4
P
1
3
P
1
2
P
1
1
P
1
0
P
9
P
8
P7
P6
GR12
P5
P4
P3
P2
P1
-28V
GR10
GR11
GR9
G
R
8
G
R
7
G
R
6
G
R
5
G
R
4
G
R
3
G
R
2
G
R
1
GND
LED3
-16.0 -18.0 -18.0 -18.0
3.3
3.3
L
E
D
V
+
3
E
I
R
-
2
5
.
1
-
2
5
.
1
-
2
0
.
5
-
2
6
.
8
-
2
6
.
8
-
2
6
.
8
-
2
0
.
5
-
2
0
.
5
-
2
2
.
7
-
2
0
.
5
-
2
0
.
5
-
2
2
.
7
-
2
6
.
8
-
2
6
.
8
-
2
0
.
5
-
2
2
.
7
-
2
2
.
7
-
2
6
.
8
-
1
9
.
7
-
1
9
.
7
F
L
+
F
L
+
P
1
6
P
1
5
P
1
4
P
1
3
P
1
2
P
1
1
P
1
0
DVDCD
TRACK ALL REPEA
P
9
P
8
P
7
P
6
P
5
P
4
P
3
P
2
P
1
G
8
G
7
G
N
D
P
O
W
E
R
S
W
2
G
N
D
P
O
W
E
R
S
W
2
G
N
D
DEG150
(OPERATION2 PCB)
SW667:POWER
Switch
61 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
OPERATION PCB ASSY
(WYXZT5, WVXZT5 : A2L502A270)
(WSXZT5 : A2L506A270)
Switches
SW652 : DOWN
SW653 : ENTER
SW654 : RIGHT
SW655 : RETURN
SW656 : MENU
SW657 : UP
SW658 : TOP MENU
SW659 : LEFT
SW660 : STOP
SW661 : HOME MENU
SW662 : + SKIP
SW663 : PLAY
SW664 : SKIP
SW665 : PAUSE
SW666 : EJECT
IC
1
1
0
1
1
12 13 14 15 16
2
3
4
40 41 42 43 44
5
6
7
8
9
S
W
6
6
8
E
V
Q
1
1
L
0
5
R
U
S
B
1 10 11 12 13 14 15 16 17 18 19 2 5 6 7 8 9
CP602
USB-A1D102F-4B4N
USB CONNECTOR
1
2
3
4
CD601
2H0B1003
FFC(1.0mm pitch)
CD605
CU241203
SHIELD CABLE
D
6
6
5
1
S
S
1
3
3
D
6
6
9
1
S
S
1
3
3
M
S
1
_
2
CP605
A2001WR2-4P
1
2
3
4
CP601
00_6232_011_102_800+
1
10
11
2
3
4
5
6
7
8
9
R
6
5
7
1
0
K
R
6
5
6
1
K
R
6
5
8
1
0
K
R662
100K
R654
2.2
R
6
5
5
1
K
T
P
6
6
2
W
8
0
3
W806
(W802)
W804
C
6
1
1
4
7
P
C
H
C
6
1
0
4
7
P
C
H
C
6
7
5
1
B
C
6
7
6
0
.
1
B
C608
0.01 B
C
6
5
8
0
.
1
B
C
6
5
4
0
.
0
1
B
C
6
0
1
1
B
C604
33P CH
C605
1 B
C
6
5
3 4
7
6
.
3
V
K
A
_
P
B601
HCB2012K-600T25
(60 OHM 2.5A)
B
6
0
2
H
C
B
2
0
1
2
K
-
6
0
0
T
2
5
(
6
0

O
H
M

2
.
5
A
)
OTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
FLDC-
FLDC+
P
7
P
6
P
5
P
4
P
3
P
2
P
1
G
R
8
G
R
7
G
R
6
G
R
5
G
R
4
G
R
3
G
R
2
G
R
1
SW2
-28V
SW1
USB+5V
P
1
4
P
1
5
P
1
6
USBN
USBP
STB
FP_SCK
FP_DI
FP_DO
USB+5V
USBP
USBN
FP_SCK
FP_DI
STB
FP_DO
IR
V+3E
G
R
3
G
R
2
G
R
1
L
E
D
FLDC+
-28V
FLDC-
V+3E
GND
PCB270
DEG149
STB
12
V
D
D
3.2
0
0
0 -19.0 -15.6 .0
LED1
LED2
LED4
CLK
V
D
D
44
.0 -16.0 -16.0 0
0
2.9
3.2
0.7
3.4
NC
K2
K1
DI
DO
OSC
GND
P
1
6
P
1
5
P
1
4
G
R
3
G
R
2
G
R
1
GND
LED3
0
0
0
NC
NC
NC
3.3
3.3
+5V
GND
USB_DN
USB_DP
-
2
5
.
1
-
2
5
.
1
-
2
5
.
1
-
2
5
.
1
-
2
5
.
1
-
2
5
.
1
-
2
5
.
1
-
2
5
.
1
-
2
0
.
5
-
2
6
.
8
-
2
6
.
8
-
2
6
.
8
-
2
0
.
5
-
2
0
.
5
-
2
2
.
7
-
2
2
.
3
-
2
2
.
3
F
L
-
F
L
-
LL REPEAT A B
P
7
P
6
P
5
P
4
P
3
P
2
P
1
G
8
G
7
G
6
G
5
G
4
G
3
G
2
G
1
DGND
FLDC+
-28V
FLDC-
V+3E
IR
STB
DO (F to M)
CLK
DGND
DI (M to F)
USBN
USB+5V
GND(USB)
USBP
1
C612
0.1 B
62 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
10.9 POWER PCB ASSY(1/2)
F501
T1.6A_L_250V
50T016H
L501
SS11V-03550NT-CH
COIL,LINE FILTER
1 2
3 4
FH501
EYF-52BCY
FH502
EYF-52BCY
IC504
PS2561AL1-1-V(W)
PHOTO COUPLER IC
1
2 3
4
R510_1
2.7 1W
R
5
0
2
_
1
1
.
5
1
W
1.6A 250V
1.6A 250V
REPLACE ONLY WITH THE SAME TYPE FUSE
:FOR CONTINUED PROTECTION AGAINST FIRE HAZARD,
CAUTION
N'UTILISER QUE DES FUSIBLE DE MEME TYPE
:POUR UNE PROTECTION CONTINUE LES RISQUES D'INCEIE
ATTENTION
IC501 KIA431A-AT
VOLTAGE CTL IC
1 2 3
R511
68 1/4
R507
10 1/4W
J501
YKE31-0148N
AC INLET
1
2
T501
81291354
10
11
12
13
14
15
16
2
3
4
6
7
8 9
CD501_2 06158802
AC220V-240V_50Hz
/60Hz(EU)
C
5
2
0
SH501
YQ-12
ATTENTION
CAUTION
DESCRIBED IN PARTS LIST ONLY
ARE
C
5
1
1
_
2
4
7
4
0
0
V
N
H
G
C
5
2
1
1
0
0
0
1
6
V
Z
L
P
C
5
2
3
D
5
0
8
M
T
Z
J
5
.
6
B
D506
1N4005-EIC
D503
1N4005-EIC
D515
1S40-E
D
5
0
9
R
L
1
0
6
F
-
E
D519
1F5-E
D527
SR240-F
D510
SF26-F
D512
1H3-E
D513
1H3-E
D502
1N4005-EIC
D
5
1
1
1
F
5
-
E
D505
1N4005-EIC
R
5
1
8
3
3
K
R513
6.8K
R
5
0
3
1
.
5
M
1
/
2
W
R
5
1
6
1
0
R515
1K
R514
1K 1/4W
R505
22 1/4W
R
5
1
2
1
0
0
K
1
/
2
W
R
5
1
7
1
2
K
1
%
R
5
0
4
6
8
0
K
C
5
1
5
0
.
0
1
4
0
0
V
P
P
C
5
0
5
1
0
0
P
2
K
V
R
C540
0.0068 B C503
0.1 B
C
5
0
8
6
8
0
P
C
H
C514
470P 500V B
C
5
0
2
0
.
2
2
2
7
5
V
E
C
Q
U
L
C
5
1
3
4
7
P
2
K
V
S
L
C
5
1
6
0
.
0
0
3
3
2
5
0
V
K
X
I
C
5
0
2
S
T
R
-
A
6
1
5
9
M
P
O
W
E
R

C
T
L

I
C
1 2 3 4
5 6 7 8
C
5
2
2
C
5
0
6
2
.
2
5
0
V
K
A
_
P
C
5
0
9
1
0
5
0
V
Y
K
_
P
B
5
0
1
W
4
B
R
H
3
.
5
X
6
X
1
.
0
X
2
DURING PLAYBACK.
MEASURED WITH THE DIGITAL TES
OF PRINTING AND SUBJECT TO CHA
NOTE:THIS SCHEMATIC DIAGRAM IS THE
POWER SCHEMATIC DIAGRAM
1.6A 250V{F501}
1.6A 250V{F501}
2.39 0 4.69
NC
0
0
0
0
0
0
130
130
130
-22.5
-22.5
NN
L
GND OUT IN
9.9 0
3.9 10.9
NC
0
0
0
N
C D D
O
C
P
V
C
C
G
N
D
F
B
/
O
L
P
S
T
A
R
T
U
P
17.5 3.9 0.1
130 130 130
0
0 NC
CHASSIS GND
* The parts except mark cannot be changed.
On that occasion, replace whole Assy.
63 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
IS NON POLAR ONE.
THE ALUMI ELECTROLYTIC CAPACITOR MARKED NP
THE RESISTOR MARKED F IS FUSE RESISTOR. NOTE:
L503
22uH
TSL0808
L505
22uH
R529_1
220 1W
R510_1
2.7 1W
IC501 KIA431A-AT
VOLTAGE CTL IC
1 2 3
R511
68 1/4W
Q506
KTA1504S_Y_RTK
PROTECT
IC503
PQ070XF01SZH
+6V REG (DVD MOTOR) IC
1 2 3 4
C
5
2
0
1
0
0
5
0
V
Y
K
_
P
CD502
E82G3301
CORD CONNECTOR
CD7301
2H0C3002
FFC(1.25mm pitch)
CD6003
TD-OR0201R
TM601
076E0PP121
BT601
R6P(AR)XICI
UM-4
C
5
2
1
1
0
0
0
1
6
V
Z
L
_
P
C
5
2
3
4
7
0
2
5
V
Y
K
_
P
C
5
2
6
4
7
0
6
.
3
V
Y
K
_
P
CP502
A2001WV2-16P
1
10
11
12
13
14
15
16
2
3
4
5
6
7
8
9
CP503
IMSA-9604S-12C
A/V for 21PIN
1
10
11
12
2
3
4
5
6
7
8
9
D
5
1
7
M
T
Z
J
2
.
2
B
D
5
2
3
M
T
Z
J
3
.
6
B
D533
MTZJ2.2B
D
5
3
1
M
T
Z
J
2
7
B
D
5
2
8
M
T
Z
J
5
.
1
B
D
5
3
5
M
T
Z
J
5
.
1
B
D
5
3
6
M
T
Z
J
3
.
0
B
Q503
KTA1504S_Y_RTK
-28V CTL
Q504
KTA1281-Y(GP)
FL+ P.CON SW
Q513
KTA1504S_Y_RTK
FL+ CTL
Q510 KTA1281-Y(GP)
P.CON+12V SW
Q505
KRC102SRTK
P.CON SW
D534
1SS133
D
5
2
1
1
S
S
1
3
3
D
5
2
0
1
S
S
1
3
3
D
5
2
2
1
S
S
1
3
3
D515
1S40-E
D519
1F5-E
D527
SR240-F
D510
SF26-F
D512
1H3-E
R
5
1
8
3
.
3
K
+
-
1
%
R
5
3
1
1
0
K
R546
3.3K +-1%
R545
22K+-1%
R
5
2
4
1
K
1
/
4
W
R
5
1
9
3
.
3
K
R
5
3
9
4
.
7
K
13
K
R
5
2
3
2
2
K
R527
100
R
5
0
6
1
0
0
R
5
3
8
2
2
K
R
5
1
6
1
0
R515
1K
R
5
0
9
1
K
R
5
3
0
5
6
0
1
/
4
W
R
5
4
4
1
0
K
R548
1K
R528
22K
1/4W
R514
1K 1/4W
R
5
2
6
6
.
8
K
+
-
1
%
R
5
4
0
6
8
0
R
5
4
3
4
.
7
K
+
-
1
%
R
5
4
1
5
.
6
K
+
-
1
%
R
5
4
2
4
7
0
+
-
1
%
R
5
1
7
1
.
2
K
+
-
1
%
R525
100
R547
22
R
5
3
6
1
0
K
R537
1K
R534
100 1/4W
W817
W825
C
5
0
1
0
.
0
1
B
C
5
2
4
1
0
0
P
C
H
C540
0.0068 B C503
0.1 B
C541
0.01 B
C
5
3
6
2
2
0
6
.
3
V
Y
K
_
P
C
5
1
7
2
2
0
2
5
V
Y
K
_
P
C
5
2
8
2
.
2
5
0
V
K
A
_
P
C
5
2
7
1
0
0
1
0
V
Y
K
_
P
C
5
2
2
1
0
0
0
6
.
3
V
Z
L
_
P
C
5
1
9
2
2
3
5
V
Y
K
_
P
C
5
3
1
1
0
0
1
6
V
Y
K
_
P
C
5
3
8
2
2
0
6
.
3
V
Y
K
_
P
C
5
3
5 3
3
0
1
6
V Y
K
_
P
Q501
KTC3875S_Y_RTK
PROTECT
Q502 KTC3209-Y(GP)
-28V P.CON SW
Q515 2SD1835S/T-AA
P.CON+5V REG
Q512
KTC3875S_Y_RTK
FL+ CTL
Q509
KTC3875S_Y_RTK
REG+12V CTL
Q511
KTC3875S_Y_RTK
REG+12V CTL
B502
HCB2012K-600T25
(W023)
PLAYBACK.
ED WITH THE DIGITAL TESTER
OLTAGE EACH PART WAS
ING AND SUBJECT TO CHANGE WITHOUT NOTICE.
EMATIC DIAGRAM IS THE LATEST AT THE TIME
W
8
1
9
GND
P.CON+D5V
AT+3.3V
P.CON+12V
AMP_A_OUT_R
AMP_A_OUT_L
G/Y_VIDEO
B/U_VIDEO
R/V_VIDEO
CVBS/C_VIDEO
P-H/I-L_RGB-H
ASP/FS
A_GND
G/Y_VIDEO
B/U_VIDEO
R/V_VIDEO
P-H/I-L_RGB-H
ASP/FS
CVBS/C_VIDEO
AMP_A_OUT_L
AMP_A_OUT_R
FROM/TO VIDEO
FROM/TO POWER PORT
(CP4003_1)
DPG017
PCB240
TO 21PIN/D-TERMINAL/DIGITAL
6.8 0.6
0
2.8
0
0
2.39 0 69
NC
0
9.9
0
3.2
0
3.2
P.CON+12V
P.CON+5V
FL DC-
FL DC+
GND
GND
AT+12V for MUTE
P.CON+6V
-28V
GND(M)
GND(D)
AT+3.3V
AT+3.3V
P.ON-H(STBY L)
GND OUT IN
GND
AUDIO L
GND
AUDIO R
RGB-H
CVBS
FS
G
B
R
GND
GND
(CP7301)
19.0
0.6
0
28.4
28.4
27.8
5.8
5.1 7.0
19.7
19.0
20.7
ACCESSORY
GND(USB)
USB+5V
IN GND OUT ADJ
7.0 5.9 0 1.2
20.8
21.5 21.6
4.5
12.3
5.0
4.5
12.9
5.1
12.6
12.3
12.9
POWER PCB ASSY (1/2)
(A2L502A240)
64 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
10.10 POWER PCB ASSY(2/2)
Q8
K
D
D
8
1
0
5
M
T
Z
J
6
.
8
B
D
8
1
0
3
M
T
Z
J
6
.
8
B
D
8
1
0
4
M
T
Z
J
6
.
8
B
CP8102
E8223401
1
2
Q8102
KTA1504S_Y_RTK
21PIN CTL DRV
Q8104
KRC104SRTK
DVD_RGB_H_OUT
D
8
1
0
1
1
S
S
1
3
3
R8105
390 1/4W
R8101
4.7K
R
8
1
2
0
1
1
/
4
W
R
8
1
0
8
8
.
2
K
R
8
1
0
4
6
.
8
K
R
8
1
0
3
4
7
0
1
/
4
W
R
8
1
0
2
5
6
K C
8
1
0
1
0
.
0
0
1
B
C
8
1
0
6
0
.
0
0
1
B
C
8
1
0
5
0
.
1
B
6
C8113
470 6.3V YK_P
6.3
Q8101
KTC3875S_Y_RTK
21PIN CTL IN
B8101
MMZ1608R102CT
DURING PLAYBACK.
P.CON+D5V
AT+3.3V
P.CON+12V
P-H/I-L_RGB-H
ASP/FS
AMP_A_OUT_R
AMP_A_OUT_L
G/Y_VIDEO
B/U_VIDEO
R/V_VIDEO
CVBS/C_VIDEO
A_GND
21PIN/D-TERMINAL/DIGITAL SCHEMATIC DIAGRAM
FROM POWER
(CP8001)
SPDIF
GND
0
3.2
3.3
0
0
3.2
11.4
0
0
11.4
12.1
12.1
65 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F CAUTION: DIGITAL TRANSISTOR
Q8105
KRA102SRTK
DVD_RGB_H_OUT
J8101
MRC-021V-07_A
21PIN CONNECTOR
1
1
0
1
1
1
2
1
3
1
4
1
5
1
6
1
7
1
8
1
9
2
2
0
2
1
3
4
5
6
7
8
9
OS8101
RFT5CB1
OPTICAL
1
2
3
H E
J8102
RCA-117-01
COAXIAL
1 2
L8101
10uH 0405
CP8102
E8223401
1
2
104
04SRTK
B_H_OUT
R
8
1
0
7
1
.
8
K
R
8
1
2
4
1
0
0
K
R8114
220 1/10W +-1%
R8115
220 1/10W +-1%
R8123
68
+-1%
R
8
1
2
2
2
2
0
R8106
2.4K
R
8
1
2
1
3
.
9
K
R8110
68 1/10W +-1%
R8112
68 1/10W +-1%
R8113
75 1/10W +-1%
R8111
68 1/10W +-1%
R8109
68 1/10W +-1%
TP8101
TP8102
C8119
1 B
C
8
1
0
3
1
5
0
P
C
H
C
8
1
1
6
3
3
P
C
H
C
8
1
0
7
0
.
0
0
1
B
C
8
1
1
1
0
.
0
0
1
B
B
C
8
1
2
0
0
.
1
B
C8118
100 10V YK_P
C8104
1 50V KA_P
C8114
470 6.3V YK_P
C8115
1000 6.3V YK_P
C8113
470 6.3V YK_P
C8112
1000 6.3V YK_P
Q8103
KTC3875S_Y_RTK
COAXIAL DRV
HE DIGITAL TESTER
CH PART WAS
C
8
1
2
1
1
0
0
P
ASPDIF
COAXIAL
D_GND
21PIN_R
21PIN_L
21PIN_CTL
G/Y_VIDEO_OUT
B/U_VIDEO_OUT
R/V_VIDEO_OUT
BLANKING_OUT
CVBS_VIDEO_OUT
GND
VCC
INPUT
DPG017
PCB240
(CP8001)
NC
NC
NC
NC
NC
4.9
2.1
2.7
SPDIF
GND
0
3.2
3.3
0
0
3.2
* The parts except mark cannot be changed.
On that occasion, replace whole Assy.
POWER PCB ASSY (2/2)
(A2L502A240)
5
6
8
7
1
2
3
4
66 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
10.11 WAVEFORMS
MPEG/MICON/DSP
VIDEO
AUDIO/JACK
Note : The encircled numbers denote measuring point in the schematic diagram.
1
2
3
4
5
6
7
8
9
10
11
DVD MT PCB ASSY
12
13
14
15
IC4002-pin238 (XTALO)
V:200 mV/div. H:500 s/div.
IC4002-pin146 (SDCLK)
V:0.5 V/div. H:2 ns/div.
IC4002-pin215 (ASPDIF)
V:1.0 V/div. H:200 ns/div.
IC4002-pin231 (ACLK)
V:1.0 V/div. H:20 nsec/div.
J8001-pin3 (L_Out)
V:1.0 V/div. H:500 sec/div.
J8001-pin2 (R_Out)
J8002-pin3 (SL_Out)
J8002-pin2 (SR_Out)
J8002-pin6 (CENTER_Out)
J8002-pin5 (LFE_Out)
J7302-pin6 (CVBS_Out)
V:200 mV/div. H:10 sec/div.
J7302-pin5 (Y_Out)
J7302-pin3 (U_Out)
J7302-pin2 (V_Out)
J7304-pin3 (S_Y_Out)
67 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
OPERATION PCB ASSY
IC651-pin5 (OSC)
21PIN/D-TERMINAL/DIGITAL
DISPLAY
DVD MT PCB ASSY
16
J7304-pin4 (S_C_Out)
1
1
2
3
4
5
6
7
8
J8101-pin11 (G/Y_Video_Out)
J8101-pin7 (B/U_Video_Out)
J8101-pin15 (R/V_Video Out)
J8101-pin19 (CVBS_Video_Out)
J8101-pin1 (21PIN_R)
J8101-pin3 (21PIN_L)
J8102-pin2 (COAXIAL_Out)
V:500 mV/div. H:200 nsec/div.
OS8101-pin1 (OPTICAL_Out)
V:1.0 V/div. H:200 nsec/div.
POWER PCB ASSY
68 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
11. PCB CONNECTION DIAGRAM
11.1 LOADING MOTOR and SW
NOTE FOR PCB DIAGRAMS :
1. Part numbers in PCB diagrams match those in the schematic
diagrams.
2. A comparison between the main parts of PCB and schematic
diagrams is shown below.
3. The parts mounted on this PCB include all necessary parts for
several destinations.
For further information for respective destinations, be sure to
check with the schematic diagram.
4. View point of PCB diagrams. Symbol In PCB
Diagrams
Symbol In Schematic
Diagrams
Part Name
B C E
D
D
G
G
S
S
B C E
B C E
D G S
B C E B C E
B C E
Transistor
Transistor
with resistor
Field effect
transistor
Resistor array
3-terminal
regulator
Capacitor
Connector
P.C.Board Chip Part
SIDE A
SIDE B
SIDE A SIDE A
SIDE B SIDE B
SW
LOADING MOTOR
(INSERTED PARTS)
LOADING MOTOR
(CHIP MOUNTED PARTS)
D E D 0 2 1 A
D E D 0 2 1 A
DED020A
S
W
2
C
D
2
3
0
1
M2602 M2601
SW1
CD2302
M2603
1
5
WH
BR
B
R
W
H
Y
E
G
R
69 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
11.2 DVD MT PCB ASSY
SIDE A SIDE A
1
65
129
193
R5919
R5920
IC4005
I
C
4
0
0
2
NR4002
X4001
C
4
0
6
9
R4082
R4083
R
4
0
7
1
R
4
0
7
0
C4050
C
4
1
2
3
CP2303
C
P
2
3
0
2
I
C
4
0
0
4
C
P
4
0
0
2
R
4
0
8
4
C
4
0
9
1
C
4
1
0
4
W
8
4
6
C4114
C4115
NR4001
R
4
0
3
5
C
4
1
3
3
CP2301
W
8
2
6
C4098
C4112 C4093
R4011
R4012
C4099
B
4
0
0
2
C4095
C
4
0
9
4
IC4006
C
4
0
9
6
R
4
0
1
3
B
4
0
0
1
C
4
0
5
6
I
C
5
9
0
2
C5923
R5921 C5922
R5901 C5924
W815
R
4
0
1
8
R
4
0
1
9
R
4
0
1
7
R
4
0
1
5
R
4
0
1
6
C
4
0
3
2
C
4
0
3
1
C4042
C
4
0
4
4
C
4
0
4
7
R
4
0
2
4
R4025 R
4
0
2
7
R
4
0
4
6
R
4
0
4
7
C4011
R
7
3
2
0
R
7
3
1
9
I
C
7
3
0
1
C7329
CP8001
C7316
C7314 C7315
J
7
3
0
2
C7318
CP7301
B7305
J
7
3
0
4
R
7
3
0
1
W877
B
7
3
0
2
C7319
C7312
C
7
3
0
9
C
7
3
0
8
C7307
C7306
C7304
C8067
Q8011
D
8
0
0
4
R8001
R8041
C8040
C8036
C8041
R
8
0
1
8
IC8003
C8016
C8050
R8038 R8023
Q8012
R8081
Q
8
0
2
3
R
8
0
8
5
R8090
R8088
R8091
C8027
C8068
R
8
0
8
0
Q
8
0
2
4
IC8008
C8058
C8069
C8017
C8029
J
8
0
0
1
IC8007
IC8002
C
8
0
0
2
R
8
0
0
9
R
8
0
0
5
Q
8
0
0
1
C8045
R
8
0
2
4
R
8
0
2
6
Q8014
C8035
R
8
0
3
5
C8048
C8033
C8061
C8060 R
8
0
1
9
C8032
C8072
C8047
R
8
0
3
3
C8065
C8066
J
8
0
0
2 IC8004
IC8005
R
8
0
2
9
R
8
0
2
2
R
8
0
9
4
R
8
0
7
1
R
8
0
7
3
R8049
R8027
R
8
0
9
5
R8078
R
8
0
7
9
R8070
Q8016
Q8018
C
8
0
4
3
C8073
C8026
C8019
C8014 C8037
C8064
C
8
0
2
3
C8020
C8034 C8015
R4038
C
8
0
0
7
Q
8
0
1
3
C
8
0
0
8
C4119
C
4
1
0
3
R
4
0
4
3
C4060
W
8
3
3
I
C
2
3
0
1
Q2303
Q2305
C2321
Q2302 Q2304
C2320
R
2
3
0
6
R
2
3
0
7
Q
2
3
0
1
R
2
3
0
8
R
2
3
0
9
R
2
3
3
8
R2319
R2331
R2342
C2322
C2323 C2312
C
2
3
0
5
R2317
R2311
C
2
3
1
1
R
2
3
1
0
C
2
3
0
7
W
8
0
2
R2325
R2312 R2313
C2306
R2304
C2301
C8028
C8031
IC4001
W
8
5
5
IC7302
C7322
C4117
C
4
0
2
4
R
2
3
1
6
C
4
0
6
3
W889
C
4
0
6
2
C4023
C4100
W
8
3
9
W
8
6
1
W843
R8043
R4059
Q8004
Q
8
0
0
3
Q2306
CP4003_1
C4142
IC4007
C4078
Q4003
R
4
0
0
7
R
4
0
1
0
IC8001
C
8
0
0
4
I
C
4
0
0
9
W
8
4
9
C4137
C
4
1
4
0
R
4
0
7
4
R
4
0
7
3
R
4
0
7
2
C4141
C
4
1
3
5
C
4
1
3
4
C
4
1
2
2
C
4
1
3
2
B
5
9
0
1
R
4
0
6
3
W
8
3
0
L
5
9
0
1
L
5
9
0
2
B
4
0
1
0
W
8
3
7
C
P
5
9
0
1
R
7
3
0
2
R
7
3
0
3
C2304
C
5
9
2
5
IC4003
C
4
1
4
3
C
P
4
0
0
4
Q8002
R2329_1
Q5902
D
4
0
0
2
D
4
0
0
3
C
4
1
0
2
R
8
0
2
8
R4028
C4077
C
4
0
7
6
C
2
3
0
8
R
2
3
1
8
R2327
C
4
0
0
3
C
4
0
0
2
C4001
C
4
0
0
7
C4038
L4001
C8038
W
8
7
9
W842
W841
C2325_1
R
8
0
0
7
R
8
0
0
8
S
H
4
0
0
1
B
4
0
0
7
DMG100A
DVD MT PCB ASSY
70 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
SIDE B SIDE B
R
4
0
6
0
C
4
0
7
1
C
4
0
8
0
C
4
0
8
1
C
4
0
8
2
C
5
9
2
1
C
4
0
8
8
C
4
0
6
8
C
4
0
7
2
C
4
0
7
3
C
4
0
5
4
C
4
1
0
1
C
4
1
2
0
C
4
0
5
2
C
4
0
6
4
R
4
0
0
1
C
4
0
5
5
C
4
0
5
1
R
4
0
1
4
R
4
0
0
4
C
4
0
2
2
C
4
0
4
0
C
4
0
2
5
R4044
C
4
0
2
1
R4054
C
4
0
2
9
R
4
0
3
9
C
4
0
3
6
W
8
1
3
C
4
0
3
7
R
4
0
0
3
C
4
0
2
0
C
4
0
0
8
C
4
0
0
9
R
4
0
0
5
C
4
1
0
5
C
4
0
0
5
C
4
0
1
9
C
4
0
1
3
C
4
0
1
7
C
4
0
1
6
C
4
0
1
5
C
4
0
1
4
C
4
0
2
6
W816
R
4
0
2
0
C
4
0
2
7
C
4
0
2
8
C
4
0
3
3
R
4
0
2
2
C
4
0
3
4
C
4
0
3
5
C
4
0
4
1
C
4
0
4
3
C
4
0
4
9
C
4
0
4
8
C
4
0
4
6
C
4
0
6
1
R
4
0
6
9
R
4
0
6
8
C
4
0
8
4
C
4
0
6
5
R
4
0
0
6
R
4
0
0
8
C
4
1
1
0
C
4
0
6
6
C
4
0
6
7
D
7
3
0
9
D
7
3
1
2
D
7
3
0
8
D
7
3
1
1
R
7
3
2
1
D7310
D
7
3
0
7
C
7
3
3
0
B
7
3
0
1
C
7
3
1
7
C
7
3
0
2
C
7
3
1
3
R
7
3
1
5
C
7
3
0
5
R
4
0
6
7
C
4
0
8
3
R
4
0
6
6
C
4
0
7
4
R4065
R4064
R
4
0
6
1
R
4
0
0
2
W
8
0
4
C
8
0
5
4
Q8009
C
8
0
3
0
C
8
0
0
6
R
8
0
9
9
C
8
0
5
1
R
8
0
6
3
R
8
0
6
4
C
8
0
5
5
R8066
C
8
0
6
2
C
8
0
4
6
R
8
0
6
1
R
8
0
7
5
R
8
0
8
7
R
8
0
8
2
Q8019 Q8021
C
8
0
0
5
R
8
0
9
6
Q8010
Q8008
D
8
0
0
3
R
8
0
2
1
D
8
0
0
5
R8002
R8025
C
8
0
3
9
C
8
0
1
3
D
8
0
0
6
R
8
0
0
3
R8017
R
8
0
4
6
R
8
0
1
2
R
8
0
5
4
C
8
0
5
2
C
8
0
5
7
R
8
0
5
8
R
8
0
5
5
C
8
0
4
4
R
8
0
5
2
R
8
0
3
1
R
8
0
4
8
C
8
0
5
6
R
8
0
7
7 Q8017
R8069
R
8
0
7
6
C
8
0
1
0
R
8
0
3
6
C
8
0
4
9
R8053
R
8
0
5
0
C
8
0
5
9
C
8
0
0
9
R
8
0
4
5
R
8
0
6
8
C
8
0
5
3
R
8
0
7
4
Q8015
R
8
0
7
2
R
8
0
9
2
R
8
0
9
3 R4058
W
8
3
2
W822
W
8
2
1
R
4
0
5
0
R4051
C
4
0
3
0
C
4
0
1
2
R4026
C
2
3
0
3
C
2
3
0
2
R
4
0
4
0
W
8
6
8
W
8
1
9
W
8
5
6
R
4
0
0
9
C
4
1
2
8
W807
B
4
0
1
4
C
5
9
0
1
B
4
0
1
5
R8065
B
4
0
1
8
Q4004
C
4
1
3
0
B
4
0
1
6
R
8
0
5
9
W864
W
8
6
2
C
4
1
3
1
NR4003
R
4
0
3
4
NR2301
Q7302
R
4
0
4
8
D4005
W
8
4
4
R
4
0
2
1
C
8
0
2
5
Q5906
C
5
9
2
0
W
8
4
5
R
8
0
6
7
C
8
0
6
3
Q8020
R7304
R
7
3
0
5
R
7
3
1
6
R7317
W
8
4
8
W
8
5
1
W
8
5
0
R8020
Q4002
B
7
3
0
4
C
4
0
8
6
C
4
0
7
5
W
8
5
8
W
8
2
0
W
8
4
0
W878
B8001
R
8
0
0
6
DMG100A
DVD MT PCB ASSY
71 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
11.3 OPERATION PCB ASSY
SIDE A SIDE B
O
P
E
R
A
T
I
O
N

P
C
B

A
S
S
Y
O
P
E
R
A
T
I
O
N

P
C
B

A
S
S
Y
23
34
1
12
S
W
6
6
7
D
6
6
0
S
W
6
6
5
S
W
6
6
4
S
W
6
6
2
S
W
6
6
0
S
W
6
6
3
W
0
2
1
S
W
6
6
6
D
6
5
9
D657
D
6
5
8
S
W
6
6
8
D656
D655
D654
D652
W017
S
W
6
6
1
S
W
6
5
8
S
W
6
5
9
S
W
6
5
2
S
W
6
5
5
S
W
6
5
6
W
0
0
1
D
6
5
1
S
W
6
5
7
S
W
6
5
4
W005
W004
W016
W013
W012
W014
D665
R
6
6
4
W018
W
0
2
2
C
6
7
4
C
6
5
3
R666
W006
W011
W
0
0
2
W019
W020
V
6
5
1
C
P
6
0
1
C
P
6
0
5
W007
C
P
6
0
3
CP604
W
0
2
3
CP602
O
S
6
5
1
S
W
6
5
3
W
8
0
4
W
0
0
3
D667
C651
R657
C611
R655
R658
C610 R656
IC651
C654
B601
C675
R
6
6
2
R
6
5
4
C605
C604
C676
C658
C601
C608
W
8
0
3
B
6
0
2
W806
D
E
G
1
4
9
A
D
E
G
1
5
0
A
D
E
G
1
4
9
A
D
E
G
1
5
0
A
G
A
3
0
C
5
G
A
3
0
C
5
72 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
11.4 POWER PCB ASSY
SIDE A SIDE A
J
8
1
0
1
O
S
8
1
0
1
J
8
1
0
2
J
5
0
1
FH502 FH501 F501
L
5
0
1
C502
R
5
0
3
D505
D502
D503
D506
T501
IC502
D511
W
0
0
6
W
0
0
3
D
5
1
3
C
5
1
4
I
C
5
0
4
C509
C505
R512
C506
D
5
0
8
C513
R
5
0
7
W002
B501
S
H
5
0
1
R505
C
5
1
6
IC501
D
5
1
5
D527
C517
C522 C520
D512
D510
C521
C523
IC
5
0
3
C531
W013
W012
Q515
C535
W021
W
8
1
7
C527
R
511
D517
D534
W022
W007
W
0
1
7
Q502
C528
R
5
2
8
R
5
3
0
W
0
0
8 C538
L503
C8104
C8118
C
P
5
0
3
D8104
L8101
D8101
R
8
1
0
3
R
8
1
0
5
C8112
D
8
1
0
3
C8113
D
8
1
0
5
C8114
W
0
2
3
C8115
R
8
1
2
0
W018
C536
L505
W015
D528
C526
W
0
1
4
W011
W019
W009
D533
R
5
3
4
W
0
0
5
W010
D
5
3
6
D535 D531
C519
D
5
2
3
D
5
2
0
D
5
2
2
D521
R514
CP502
W004
CP8102
W001
C
515
D
5
1
9
Q504
Q510
R510_1
R
5
2
9
_
1
R502_1
W016
D509
C511_2
R
5
2
4
W825
R
5
0
8
POWER PCB ASSY
DPG017A
RISK OF FIRE
- REPLACE AS MARKED.
G
A30C5
L
N
73 DV-610AV-S
5 6 7 8
5 6 7 8
A
B
C
D
E
F
SIDE B SIDE B
R
5
0
4
C
5
0
8
Q509
Q511
R
5
4
0
R
5
4
3
R
5
4
2
R
5
4
1
R
5
2
6
R
5
0
9
R
5
2
5
R
5
4
7
C
5
0
1
R
5
1
9
Q505
R
5
4
5
R
8
1
2
4
Q8103
B
8
1
0
1
R
8
1
2
2
R
8
1
2
3
C
8
1
0
3
R
8
1
2
1
R
8
1
0
6
R
8
1
0
7
C
8
1
2
0
C
8
1
1
9
R
8
1
1
4
C
8
1
1
1
R
8
1
1
5
C
8
1
0
7
R
8
1
1
1
R
8
1
0
2
Q8102 Q8101
R
8
1
0
4
R
8
1
0
8
R
8
1
1
0
R
8
1
1
2
R
8
1
0
1
R
8
1
1
3
C
8
1
1
6
Q8105
Q8104
C
8
1
0
1
C
8
1
0
6
R
5
3
6
Q503
R
5
3
1
R
5
4
8
R
5
3
7
Q513
R
5
4
4
Q512
R
5
1
5
C
5
4
0
C
5
0
3
R
5
1
3
R
5
1
8
R
5
1
6
R
5
1
7
R
5
3
9
Q506
R
5
0
6
R
5
3
8
R
5
2
7
Q501
R
5
2
3
C
5
4
1
C
8
1
0
5
B
5
0
2
R
8
1
0
9
R
5
4
6
C
5
2
4
DPG017A
POWER PCB ASSY
74 DV-610AV-S
1 2 3 4
A
B
C
D
E
F
1 2 3 4
12. PCB PARTS LIST
- Meaning of the figures and others in the parentheses in the parts list.
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board.
IC 301 (A, 91, 111) IC NJM2068V
5 6 2 1
1 R 0
R 5 0
5 6 1
4 7 3
NOTES: - Parts marked by NSP are generally unavailable because they are not in our Master Spare Parts List.

- The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
- When ordering resistors, first convert resistance values into code form as shown in the following examples.
Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47 k ohm (tolerance is shown by J = 5%,
and K = 10%).
560 56 10
1
561
...................................................................
RD1/4PU J
47 k 47 10
3
473
...................................................................
RD1/4PU J
0.5 R50
.................................................................................................
RN2H K
1 1R0
.................................................................................................
RS1P K
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors).
5.62 k 562 10
1
5621
.................................................................
RN1/4PC F
LIST OF ASSEMBLIES
1..DVD MT PCB ASSY A2L502A130
(WYXZT5,WVXZT5)*
(WSXZT5)*
> 1..POWER PCB ASSY A2L502A240
(*) A2L502A270 and A2L506A270 have same service parts.
But they are NOT COMPATIBLE.
DVD MT PCB ASSY
SEMICONDUCTORS
IC 2301 IC AM5766 I1UFV5766S
IC 4001 IC S-24CS04AFJ-TB-GE I5HJ0S04A0
IC 4002 IC MT1389EXE/S-L IC8K0389SX
IC 4003 IC R3112N291A-TR-FA IE1F0291A0
IC 4004 IC ES29LV160EB-70TG S2L502AF01
IC 4005 IC M12L64164A-5TG IF9J0164AE
IC 4006 IC LD1117AL-ADJ-AA3-A-R I1YF9117A0
IC 4007 IC R5523N001B-TR-F I1ZF0N0010
IC 4009 IC BA00BC0WFP-E2 I07F0C0WF0
IC 5902 IC PQ1K503M2ZPH I0GF9K5030
IC 7301 IC LA73054-TLM-E I03FG30540
IC 7302 IC SN74CBT3257PWR I5CJ032570
IC 8001 IC TC7SHU04FU I55F004FU0
IC 8003-8005 PCM1742KE/2K I17F042KE0
IC 8008 IC RC4580IDR I04J045800
OTHERS
J 7302 RCA JACK 060R451013
J 7304 JACK 063R700013
J 8001 RCA JACK 060R451012
J 8002 RCA JACK 060R451014
CP 5901 CONNECTOR PCB SIDE 06GEYJ3048
X 4001 CRYSTAL (27 MHz) 100GT02720
OPERATION PCB ASSY
SEMICONDUCTORS
IC 651 IC PT6315 IF4K063150
SWITCHES
SW652-667SWITCH TACT 0504R01T38
OTHERS
CP 602 CONNECTOR PCB SIDE 06G5AA1002
V 651 TUBE FLUORESCENT 096F80R401
OS 651 REMOTE RECEIVER 077Q040004
POWER PCB ASSY
RESISTORS
>R 511 R,FUSE 68 OHM 1/4W R65584680J
OTHERS
J 8101 SOCKET, 21PIN 063D100050
J 8102 RCA JACK 060R401122
CP 8102 CORD CONNECTOR 06E8223401
OS 8101 OPTICAL DEVICE 07AA000011

DV-610AV Service Manual

Uploaded by

Copyright:

Available Formats

DV-610AV Service Manual

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

DV-610AV Service Manual

Uploaded by

Copyright:

Available Formats

ORDER NO.

PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan

Short circuit using a

may not play, or filenames

are trademarks of Apple Inc., registered in the

Plays all versions of DivX video (including DivX 6) with

This player is compatible with WMV9 files that are encoded by

2-3: LOADING MOTOR PCB ASS'Y/ LOADING BELT

Loader Sub Assy

Loader Sub Ass'y (Bottom Side)

Rack Feed Ass'y

You might also like