CS Management Guide Novogen Brown Light GB v3

Management Guide
NOVOgen Brown Light
www.novogen-layers.com
Commercial Layers Management Guide – NOVOgen BROWN Light
TABLE OF CONTENTS
TABLE OF CONTENTS
1. FLOCK MANAGEMENT DURING THE REARING PERIOD ....................................................................... 1
CHOICE OF REARING SYSTEM AND EQUIPMENT .......................................................................... 1
STOCKING DENSITY, DRINKER SPACE AND FEEDING SPACE IN REARING .............................. 2
STARTING UP STRATEGY .................................................................................................................. 3
CLIMATE STRATEGY .......................................................................................................................... 3
GRIT AND GRAIN ................................................................................................................................. 5
2. LIGHTING PROGRAMME ............................................................................................................................ 6
GENERAL RULES ................................................................................................................................ 6
VARIOUS HOUSING AND LIGHTING SITUATIONS TO CONSIDER – EXAMPLE PROGRAMMES 8
LIGHTING PROGRAMME IN LIGHT-CONTROLLED REARING HOUSES (<0.5 LUX) .................... 10
LIGHTING PROGRAMME IN SEMI – DARK OR OPEN REARING HOUSES (>0.5 LUX)................ 11
LIGHTING PROGRAMME IN HOT CLIMATE (BETWEEN 20° NORTH AND 20° SOUTH) .............. 12
3. FLOCK MANAGEMENT DURING THE PRODUCTION PERIOD ............................................................. 13
STOCKING DENSITY, DRINKER SPACE AND FEEDING SPACE IN PRODUCTION .................... 13
TRANSFER ......................................................................................................................................... 13
LIGHTING PROGRAMME DURING THE PRODUCTION PERIOD................................................... 13
LIGHT INTENSITY MANAGEMENT DURING THE PRODUCTION PERIOD ................................... 14
MANAGEMENT OF EGG WEIGHT .................................................................................................... 14
MANAGEMENT OF EGG SHELL QUALITY ....................................................................................... 15
4. MONITORING BODYWEIGHT AND UNIFORMITY ................................................................................... 16
BODYWEIGHT CONTROL ................................................................................................................. 16
UNIFORMITY CONTROL ................................................................................................................... 16
5. BEAK TREATMENT.................................................................................................................................... 17
BEAK TREATMENT MONITORING ................................................................................................... 17
FULLY BEAKED FLOCKS MANAGEMENT ....................................................................................... 18
6. WATER MANAGEMENT ............................................................................................................................ 19
WATER MANAGEMENT DURING THE REARING PERIOD............................................................. 19
WATER QUANTITY ............................................................................................................................ 19
WATER QUALITY ............................................................................................................................... 19
7. NUTRITION ................................................................................................................................................. 22
EXAMPLE OF DIET SPECIFICATIONS FOR REARING PERIOD .................................................... 23
EXAMPLE OF DIET SPECIFICATIONS FROM 2% PRODUCTION TO 28 WEEKS......................... 24
EXAMPLE OF DIET SPECIFICATIONS FROM 28 TO 45 WEEKS ................................................... 25
EXAMPLE OF DIET SPECIFICATIONS FROM 45 TO 70 WEEKS ................................................... 26
EXAMPLE OF DIET SPECIFICATIONS FROM 70 WEEKS TO DEPLETION ................................... 27
8. HEALTH PROGRAMME ............................................................................................................................. 28
VACCINATION .................................................................................................................................... 28
PARASITES AND INSECTS MONITORING ...................................................................................... 32
TABLE OF CONTENTS
9. GENERAL FARM RULES ........................................................................................................................... 34

10. CLEANING AND DISINFECTION OF POULTRY HOUSES ...................................................................... 35
OPERATIONS PRIOR TO CLEANING ............................................................................................... 35
WASHING ........................................................................................................................................... 35
PLACING EQUIPMENT BACK INTO THE HOUSE............................................................................ 36
DISINFECTION ................................................................................................................................... 36
SANITARY PRECAUTIONS ............................................................................................................... 36
ASSESSING DISINFECTION EFFECTIVENESS .............................................................................. 36
RODENT CONTROL ........................................................................................................................... 36
RESTING PERIOD .............................................................................................................................. 37
BEFORE THE NEW FLOCK ARRIVES .............................................................................................. 37
11. PERFORMANCE TABLES ......................................................................................................................... 38
REARING TABLE ................................................................................................................................ 38
PRODUCTION TABLE ........................................................................................................................ 39
The performance data contained in this document was obtained from results and experience from our own research flocks and
flocks of our customers. In no way does the data contained in this document constitute a warranty or guarantee of the same performance
under different conditions of nutrition, density or physical or biological environment. In particular (but without limitation of the
foregoing) we do not grant any warranties regarding the fitness for purpose, performance, use, nature or quality of the flocks. NOVOGEN
makes no representation as to the accuracy or completeness of the information contained in this document.
FLOCK MANAGEMENT DURING THE REARING PERIOD

1. FLOCK MANAGEMENT DURING THE REARING PERIOD
During this period, it is necessary to reach the target bodyweight and flock uniformity to prepare the birds for the
production period. A special care has also to be given to the development of the digestive tract in order to prepare
for the fast increase in consumption at the beginning of the production period. A well-managed rearing period has
positive effects on:
• Egg production (peak of lay and persistency)
• Egg quality (egg weight, egg uniformity, shell strength)
• Liveability
To achieve those objectives, it is necessary to respect the following basics:

• Management (stocking density, drinker and feeder space, water, temperature, beak trimming…)
• Lighting programme
• Monitoring bodyweight and uniformity
• Nutrition
• Biosecurity and vaccination
CHOICE OF REARING SYSTEM AND EQUIPMENT

The rearing system and equipment have to be carefully chosen according to the equipment used in the
production farm. Feeding and drinking equipment during the rearing period should be as similar as possible to the
ones used in the future production system. It will facilitate the transfer and adaptation to the new production house;
especially for aviary/multi-tier systems, where young pullets have to be trained for a quick adaptation to use the
equipment on different levels.
REARING SYSTEM RECOMMENDED PRODUCTION SYSTEM

Cage Cage
Floor Cage / Floor / Free range
Aviary Cage / Floor / Free range / Aviary
Photos: Cage rearing system
1

Photos: Floor rearing system
Photos: Aviary rearing system
STOCKING DENSITY,
DRINKER SPACE AND FEEDING SPACE IN REARING
 Recommendations in floor system
From day old to 2 weeks of
age From 2 to 5 weeks of age From 6 weeks to transfer
age
Temperate Hot Temperate Hot Temperate Hot
climate climate climate climate climate climate
Stocking 12-15 8-10
30 birds/m2 25 birds/m2 15 birds/m2 12-14 birds/m2
density (1) birds/m2 birds/m2
Starter drinkers 1 / 80 birds 1 / 70 birds - - - -
Bell drinkers 1 / 150 birds 1 / 150 birds 1 / 100 birds 1 / 75 birds 1 / 100 birds 1 / 75 birds
Nipple drinkers 1 / 12 birds 1 / 10 birds 1 / 12 birds 1 / 10 birds 1 / 12 birds 1 / 10 birds
Starting feed
1 / 50 birds - -
pans
Linear chain
2.5 cm / bird 4 cm / bird 6 cm / bird
feeders
Pan feeders 1 / 30 birds 1 / 25 birds 1 / 25 birds
(1) In the case of 100% slat floor, stocking density can be increased by 15% from 6 weeks of age.
2

 Recommendations in cage system
From day old to 2 weeks of
age From 2 to 5 weeks of age From 6 weeks to transfer
age
Temperate Hot Temperate Hot Temperate Hot
climate climate climate climate climate climate
Stocking
130 cm² / bird 140 cm² / bird 220 cm² / bird 250 cm² / bird 350 cm² / bird 390 cm² / bird
density (1)
Nipple drinkers 1 / 15 birds 1 / 10 birds 1 / 15 birds 1 / 10 birds 1 / 12 birds 1 / 10 birds
Linear chain
2.5 cm per bird 4 cm per bird 6 cm per bird
feeders
STARTING UP STRATEGY
ALL SYSTEM
• Before chicks arrive, feed should be accessible to the chicks. Feeders should be well filled and feed should be
spread over chick paper especially close to the drinking lines. This stimulates the chicks to use the drinking
equipment.
• Feed must be regularly renewed to keep it fresh and attractive.
• Before arrival the drinking lines must be checked, so that fresh water is provided and leakage is prevented.
• Triggering the nipples or water cups encourages the birds to drink
• Unload the chicks close to drinkers and feeders.
SYSTEM SPECIFICITIES
• Floor system:
o Additional starter drinkers and feeders can be used in the first 2 weeks
o If brooding takes place in only part of the house, do not exceed a stocking density of 20 chicks
per available m2. Thus allowing chicks to spread quickly over the whole house within the first 7
days.
o In case of use of circular brooder guards (rings or surrounds):
 Choose a diameter of 3 to 4 m at day-old but ensure the ring can be enlarged 48 hours
after the arrival
 Ensure the surround can be easily removed after the birds have familiarised themselves
with the location of the drinker and feeder systems. Usually, guards can be removed 5 to
7 days after arrival.
• Cage system
o Use soft mat and/or paper on the bottom of the cage to improve the ease of movement and comfort
of the chick for the first few days. Paper must be removed by day 7 at the latest.
CLIMATE STRATEGY
Before and after arrival and starting up of the chicks, the below information can be used as guidelines for optimal
performance. Be aware that those setting depends highly on local climate conditions and must be adapted
accordingly.
3

 Before chicks arrival:
• After hatch, a chick is poikilotherm. This means that it can’t fully regulate its own bodytemperature.
Therefore it is important that the housing climate is supported at such a way that the thermoneutral
bodytemperature of 40⁰C is achieved.
• Raise the house temperature at least 36 hours before chick arrival to 29°C-30°C
• Pre-heat the whole house 30 to 40 hours prior to chick arrival ensuring the floor and system is fully
warmed before placement to 35oC.
 After chicks arrival:

• Never overheat the chicks and give them a choice within the desired temperature range.
• Take into account the temperature at chick level.
• Depending on the brooder design, place the brooders high enough above the litter (at least 1.5 m) at an
angle, to allow for uniform distribution of the chicks.
Check the chicks body temperature after start up to adjust the house temperature by gently touching the
chick cloaca with the probe of an ear thermometer. The optimal chick body temperature is 40-41 °C. It is
important to measure the body temperature of a sufficient numbers of chicks distributed in different parts
of the house.
Photos: Control of chicks temperature
• Check the distribution and behaviour of the chicks to enable you to adapt and manage the temperature
of the House:
o Good distribution and activity  correct temperature and climate
o Chicks cuddle and/or avoid large areas of the barn  temperature is too low or presence of air draft
o Chicks are panting and are lying on the ground with their wings spread  temperature is too high
Scheme: Chicks distribution example
4

GRIT AND GRAIN
To maintain an active feeding behaviour and to help the development of the digestive tract and encourage the birds
to scratch the litter, it is advised to give grit and grain to the birds from 4 to 5 weeks of age:
• Grit (insoluble stone particles of 2 to 4 mm): 3 to 5 g per week per bird, distributed over 2 or 3 days.
• Grain (broken maize, wheat): 3 g per bird every day, or every other day
• This is thrown on the litter, a few hours before the dark period
5
LIGHTING PROGRAMME
2. LIGHTING PROGRAMME
GENERAL RULES
Sexual maturity and production are largely influenced by the changes in day length to which pullets are exposed.
Carefully chosen lighting programmes will help to optimise the performance of breeders stocks. Sexual maturity and
bodyweight at sexual maturity influence the production, the egg size and the liveability, so the total number of hatching
eggs per hen housed.
It is difficult to advise a universally optimum and perfect lighting programme. The following lighting programmes are
examples and have to be considered as a guideline to help formulate a lighting programme adapted to your own
situation;
To establish your own lighting programme, it is important to take into account the following factors:
• Your location (changes in light duration (day length) during the year)
• The characteristics of the rearing unit (light-controlled, semi-dark or open house type)
• Season of the year (increasing or decreasing day length)
• Temperature (light duration at the highest temperature)
• Date of the hatch (what is the natural day length at the bodyweight targeted when light stimulation will
take place for onset of lay?)
• Growth of the flock
• Past records of performance obtained in this rearing unit
• Avoid any unwanted external lights in the dark house. It can affect the lighting program and efficiency
and induce feather pecking.
 LIGHTING PROGRAMME DURING THE FIRST WEEKS OF THE REARING PERIOD

In order to encourage skeletal development and growth, a slow step-down lighting programme is advised for all
housing conditions.
The decrease in artificial light duration during the day is then adjusted according to the housing type. For an open
house system (and above 20° Latitude), determine the natural light day length that the birds will encounter before 16
weeks of age. This will then help determine the maximum day length the flock will be given and help avoid an
unwanted early light stimulation before the flock has matured sufficiently. Early light stimulation will be promoted by
a natural increase in day length during rearing.
In dark rearing houses (and when allowed by the local regulation), it is possible to use an intermittent lighting
programme during the first two weeks of age. It allows synchronisation of the chicks’ behaviour for; eating, drinking
and resting. It can have a beneficial effect on the weakest chicks which are stimulated by the stronger ones and
improves the flock uniformity. After two weeks, switch to a regular step down lighting programme.
Table: Intermittent lighting programme

WEEK 1 WEEK 2
• 4 hours light • 8 hours light

• 2 hours darkness • 2 hours darkness
• 4 hours light • 8 hours light
• 2 hours darkness • 6 hours darkness
6
LIGHTING PROGRAMME
 LIGHTING PROGRAMME FROM 8 WEEKS OF AGE TO TARGETED AGE OF LIGHT
STIMULATION
In order to control sexual maturity and to avoid early sexual maturity at an inadequate and immature bodyweight, it
is important to avoid every day any increase in light duration (due to a natural increase in day length) during this
period.
According to the season in a dark house system a stable day length can be used between 10 weeks of age and 2-
5% of production. It will help to avoid a sexual maturity at a too early age. The light duration during this period can
also be adapted according to the growth of the pullets (10, 11 or 12 hours could be used when growth is slow).
In an open house system, the most difficult system for controlling sexual maturity, the natural day length at which the
pullets will be exposed to at 19 weeks of age will determine the light duration at the plateau to avoid any increase of
light duration before 19 weeks of age.
 INCREASING DAY LENGTH TO STIMULATE EGG PRODUCTION

After the appearance of the first eggs, the increase of artificial light duration should be adjusted according to the
production level. An increase of light duration of 30 minutes or 1 hour per week is suggested.
 LIGHTING PROGRAMME DURING PRODUCTION

Never decrease the artificial light duration during the production period as this can lead to an early decline in egg
production.
Graph: Example of lighting programme in light controlled rearing and laying houses
 LIGHT INTENSITY
A higher light intensity during the brooding period will encourage growth by promoting higher levels of activity of the
flock and a higher feed intake. After 2 or 3 weeks and according to the behaviour of the chicks, the light intensity may
be reduced to match the field conditions and the light intensity the birds will be exposed to during the production
period (degree of darkness of the rearing house and the laying house).
7
LIGHTING PROGRAMME
VARIOUS HOUSING AND LIGHTING SITUATIONS TO
CONSIDER – EXAMPLE PROGRAMMES
 Light-controlled rearing house to light-controlled laying house:
• Use a slow step down lighting programme until 6 weeks of age.
• A constant 9 hours day length from 7 weeks to light stimulation (12 hours may be used where needed
according to growth)
• Increase the light duration by 2 hours when body weight is between 1,260-1,330 g ,
• Add 1 hour and/or 30 minutes per week until 15.30 hours or 16 hours total light duration is obtained.
 Light-controlled rearing house to open or semi-dark laying house:

• A constant 9-10 hours day length from 7 to 15 weeks of age.
• Increase light duration by 2 hours when body weight is between 1,260-1,330 g.
• Add 1 hour and/or 30 minutes per week until 15.30 hours or 16 hours total light is obtained.
• Light intensity in rearing should be managed to avoid any dramatic and sudden increase in light intensity
at transfer time.
 Open or semi-dark rearing house to light-controlled laying house:

• A constant 9-10 hours (or natural day length) from 7 to 15 weeks of age.
• Increase light duration by 2 hours at 1,260-1,330 g of bodyweight when there is a decreasing day length.
• Increase light duration by 1 hour at 1,260-1,330 g of bodyweight when there is an increasing day length.
• Light intensity from transfer time should be managed to avoid any dramatic and sudden decrease of light
intensity.
 Open or semi-dark rearing house to open or semi-dark laying house:

• A constant 9-10 hours (or NDL) day length from 7 to 15 weeks of age.
• Increase light duration by 2 hours at 1,260-1,330 g of bodyweight when there is a decreasing day length.
• Increase light duration by 1 hour at 1,260-1,330 g of bodyweight when there is an increasing day length.
• Make light stimulation more effective by adding the additional hours of light in the morning instead of the
evening.
 In a hot climate:
• A constant natural day length from 12 weeks of age to 2-5% of production.
• Increase light duration by 1 hour and/or 30 minutes from 2-5% of production in the morning.
• The light on should be adapted to allow the birds to eat during the cooler part of the day.
8
LIGHTING PROGRAMME
 FLASH FEEDING
When allowed by the local regulation, it is possible to use an additional 1.00 to 1.30 hours of light with feed usually 3
hours after the lights going out, to ensure the longest period of dark remains after the lights go back out in order to
promote an optimal feed intake during the first weeks of production or to compensate for the adverse effect of high
temperature during the summer.
This extra light period may be introduced and removed during the production period at any time after the increase in
light duration at the start of lay.
Please contact the NOVOGEN technician in your area for more specific advice.
9
LIGHTING PROGRAMME
LIGHTING PROGRAMME IN LIGHT-CONTROLLED
REARING HOUSES (<0.5 LUX)
Bodyweight at
Age Age Average laying Light duration in
start of the week Light intensity
(weeks) (days) rate of the week hours
(g)
0 0 to 2 22.00 (1) 20-40 lux
1 3 to 7 20.00 (1) 20-30 lux
2 8 to 14 19.00 10-20 lux
3 15 to 21 17.00 5-10 lux
4 21 to 28 15.00 5-10 lux
5 29 to 35 13.00 5-10 lux
6 36 to 42 11.00 5-10 lux
7 43 to 49 10.00 5-10 lux
8 50 to 56 09.00 5-10 lux
9 57 to 63 09.00 5-10 lux
10 64 to 70 09.00 5-10 lux
11 71 to 77 09.00 5-10 lux
12 78 to 84 09.00 5-10 lux
13 85 to 91 09.00 5-10 lux
14 92 to 98 09.00 5-10 lux
15 99 to 105 (4) 09.00 (4) 5-10 lux
16 106 to 112 1260 - 1330 11.00 5-10 lux
17 113 to 119 1340 - 1415 12.00 5-15 lux
18 120 to 126 1410 - 1490 0-2% 13.00 5-15 lux
19 127 to 133 1480-1560 2-25% 14.00 (2) 5-15 lux

20 134 to 140 1550-1630 30-55% 14.30 5-15 lux
21 141 to 147 1610-1700 55-82% 15.00 5-15 lux
22 148 to 154 1655-1750 80-90% 15.30 5-15 lux
23 155 to 161 1690-1780 85-93% 15.30 5-15 lux
24 162 to 168 1710-1805 88-94% 15.30 (3) 5-15 lux
25 169 to 175 1725-1820 90-95% 15.30 (3) 5-15 lux
25 + 176 to 182 15.30 (3) 5-15 lux
(1) - An intermittent lighting programme can be implemented (if allowed by the local regulation)
(2) - From 19 weeks of age, flash feeding could be added (if allowed by the local regulation)
(3) - Could be increased to 16 hours according to feed consumption
(4) - According to the average egg weight requested by the market, it could be possible to light stimulate the
pullets one week earlier
10
LIGHTING PROGRAMME
LIGHTING PROGRAMME IN SEMI – DARK OR OPEN
REARING HOUSES (>0.5 LUX)
Bodyweight
Age Average laying In decreasing day In increasing day
Age (days) at start of the
(week) rate of the week length in hours length in hours
week (g)
0 0 to 2 22.00 22.00
1 3 to 7 20.00 20.00
2 8 to 14 19.00 19.00
3 15 to 21 17.00 17.00
4 21 to 28 15.00 15.00
5 29 to 35 13.00 (or NDL) 13.00 (or NDL)
6 36 to 42 12.00 (or NDL) 1200. (or NDL)
7 43 to 49 10.00 (or NDL) 10.00 (or NDL)
8 50 to 56 10.00 (or NDL) 10.00 (or NDL)
9 57 to 63 10.00 (or NDL) 10.00 (or NDL)
10 64 to 70 10.00 (or NDL) 10.00 (or NDL)
11 71 to 77 10.00 (or NDL) 10.00 (or NDL)
12 78 to 84 10.00 (or NDL) 10.00 (or NDL)
13 85 to 91 10.00 (or NDL) 10.00 (or NDL)
14 92 to 98 10.00 (or NDL) 10.00 (or NDL)
15 99 to 105 10.00 (or NDL) 10.00 (or NDL)
16 106 to 112 1260 - 1330 +2.00 (or 16.00) +1.00 (or 16.00)
17 113 to 119 1340 - 1415 +1.00 (or 16.00) +1.00 (or 16.00)
18 120 to 126 1410 - 1490 0-2% +1.00 (or 16.00) +1.00 (or 16.00)
19 127 to 133 1480-1560 2-25% +1.00 (or 16.00) (1) +1.00 (or 16.00)
20 134 to 140 1550-1630 30-55% +0.30 (or 16.00) +0.30 (or 16.00)
21 141 to 147 1610-1700 55-82% +0.30 (or 16.00) +0.30 (or 16.00)
22 148 to 154 1655-1750 80-90% +0.30 (or 16.00) +0.30 (or 16.00)
23 155 to 161 1690-1780 85-93% 16.00 +0.30 (or 16.00)
24 162 to 168 1710-1805 88-94% 16.00 16.00
25 169 to 175 1725-1820 90-95% 16.00 16.00
25+ 176 to 182
NDL: Natural Day Length

(1) - From 19 weeks of age, flash feeding could be added
11
LIGHTING PROGRAMME
LIGHTING PROGRAMME IN HOT CLIMATE (BETWEEN
20° NORTH AND 20° SOUTH)
Bodyweight at start of Average laying Light duration
Age (week) Age (days)
the week (g) rate of the week in hours
0 0 to 2 22.00
1 3 to 7 20.00
2 8 to 14 19.00
3 15 to 21 18.00
4 21 to 28 17.00
5 29 to 35 16.00
6 36 to 42 15.30
7 43 to 49 15.00
8 50 to 56 14.30
9 57 to 63 14.00
10 64 to 70 13.30
11 71 to 77 13.00
12 78 to 84 12.30
13 85 to 91 12.00
14 92 to 98 12.00 (or NDL)
15 99 to 105 12.00 (or NDL)
16 106 to 112 1260 - 1330 12.00 (or NDL)
17 113 to 119 1340 - 1415 12.00 (or NDL)
18 120 to 126 1410 - 1490 0-2% 12.00 (or NDL)

19 127 to 133 1480-1560 2-25% + 1.00 (1)
20 134 to 140 1550-1630 30-55% +1.00
21 141 to 147 1610-1700 55-82% + 1.00
22 148 to 154 1655-1750 80-90% + 0.30
23 155 to 161 1690-1780 85-93% +0.30 (or 16.00)
24 162 to 168 1710-1805 88-94% 16.00
25 169 to 175 1725-1820 90-95% 16.00
25+ 176 to 182
NDL: Natural Day Length

(1) - From 19 weeks of age, flash feeding could be added (if allowed by the local regulation)
12
FLOCK MANAGEMENT DURING THE PRODUCTION PERIOD

3. FLOCK MANAGEMENT DURING THE PRODUCTION PERIOD
STOCKING DENSITY, DRINKER SPACE AND FEEDING
SPACE IN PRODUCTION
Floor Cage System
Temperate climate Hot climate Temperate climate Hot climate
Stocking density
8-9 birds/m2 6-7 birds/m2 450 cm2/bird 540 cm2/bird
/ useable area (1)
Bell drinkers 1 cm / bird 1,5 cm / bird
Nipple drinkers 1 / 10 birds 1 / 8 birds 1 / 10 birds 1 / 8 birds
Linear chain
10 cm / bird 10 cm / bird
feeders
Pan feeders 1 / 20 birds
15 cm / bird
Perches (> 30 cm between perches and > 20 cm
between wall and perch)
2m / 1000 birds
Pop Holes
(higth > 35cm / width > 40 cm)
Individual nest = 1 nest / 7 birds
Nest
Group nest = 1m2 / 120 birds
Litter area > 250 cm2 / bird
(1) - In the case of 100% slat floor, stocking density can be increased by 15% after transfer
(2) - Depending on country regulation, greater minimum space are requested. Always comply with the law.
TRANSFER
Transfer is advised around 16 to 17 weeks of age.
• Before the appearance of the 1st eggs
• After a last vaccine planned 1 week before the transfer
• After de-worming of the flock (3 days prior the transfer)
In order to minimize the stress at transfer time, it is important to:
• Rear the birds on a similar drinking system as they will encounter on transfer.
• Increase light intensity to encourage water consumption
• Maintain temperature as close as close as possible to the temperature experienced by the pullets at the
end of the rearing period.
LIGHTING PROGRAMME DURING THE PRODUCTION

PERIOD
The light duration after transfer should be adjusted to match the light duration experienced at the end of the rearing
period. The post transfer light duration should be at least the same length as during the rearing phase. It may be
longer according to the plan for light stimulation. As the birds remain sensitive to changes in light duration, never
decrease the day length during the entire production period.
13
FLOCK MANAGEMENT DURING THE PRODUCTION PERIOD

LIGHT INTENSITY MANAGEMENT DURING THE
PRODUCTION PERIOD
It is possible after the peak of lay to reduce progressively the artificial light intensity. This may limit feed wastage,
excessive activity of the birds and reduce the risk of mortality. Please take into account that light intensity should
remain well distributed all over the house.
MANAGEMENT OF EGG WEIGHT

The egg weight profile of a flock is mainly determined by the following factors:
• Bodyweight at light stimulation (or at sexual maturity).

o The higher the bodyweight at sexual maturity the higher will be the egg weight during the laying
period.
o The lower the bodyweight at sexual maturity the lower will be the egg weight during the laying period.
o Delay the onset of the egg production to increase average egg weight during the production period.
o Plan for an earlier sexual maturity to decrease average egg weight during the production period.
• Evolution of the bodyweight during the first week of production
• Nutrition also has important effects on the evolution of the egg weight during production:
o Intake of protein or digestible amino acids
o Metabolisable energy of the feed
o Linoleic acid and oil content of the feed
Graph: Cumulative NOVOgen Brown Light egg distribution at 90 weeks according to EU egg weight
classification
50
Egg repartition per grade (%)
40
30
20
10
S M L XL
small medium large very large
<53 g 53-63 g 63-73 g >73 g
14
MANAGEMENT OF EGG SHELL QUALITY

Egg shell quality has become even more critical due to the lengthening of production cycles and the development of
automatic egg collection systems. While substantial genetic progress has been achieved, diet and feeding techniques
are key to the expression of this genetic progress.
• Egg shell quality and colour depend essentially on the hen’s ability to use its dietary calcium during shell
formation i.e. shortly before night time until oviposition. A good calcium diet during the production period
improves egg shell quality and colour and prevents bone demineralization (osteoporosis) and fractures.
The quality of the calcium in the diet is determined by the calcium presentation, i.e. particle and / or
powder form within the ration and its content in the feed. It is particularly important to increase the calcium
content after 45 weeks to satisfy the increase of calcium requirement due to bigger egg size and to
compensate for the natural shell quality decreasing with the age.
• Oyster shell is a good ingredient to improve the egg shell quality. The particle size and solubility are
usually very good for laying hensIt is possible to add 1g per bird at the end of the afternoon to promote
a better calcium intake for supplying the egg shell deposition during the night. Take care of the quality
about bacteriological level & calcium solubility to be sure to use a safe product.
• The feed distribution has also important effect on the shell quality. When possible, hens ingest more than
50% of their ration during the 6 hours prior to lights out in order to satisfy their specific calcium appetite.
A fraction of this calcium intake is stored in the gizzard. Since hens do not eat during the night
(calcification period), shell quality depends on the quantity of calcium remaining in the digestive tract at
the end of the day. Another way to improve shell quality is to encourage hens to consum calcium in the
middle of the night with the use of a flash feed when it is allowed. Please seek the advice of your local
NOVOGEN technician.
• More information on the relation between feed and egg shell quality can be found in the NOVOGEN
nutrition guide.
Table: Egg shell quality references per age
Eggshell quality
30 - 40 weeks 40 - 50 weeks 50 - 60 weeks 60 – 70+ weeks
(Newton)
Good > 41 > 40 > 39 > 38
Moderate 39 38 37 36
Poor < 38 < 37 < 36 < 35
Photo: Shell strength measure Photo: Shell colour measure
15
MONITORING BODYWEIGHT AND UNIFORMITY

4. MONITORING BODYWEIGHT AND UNIFORMITY
The main objective is to reach the appropriate bodyweight and uniformity targets at different stages of the bird’s
development:
• At the early stage (0 – 7 weeks: period of frame development)
• At sexual maturity with an even growth curve (a low bodyweight at sexual maturity could affect later
performances)
• At the start of lay to the peak of production (a growth of at least 300g from 5% of lay until 30 weeks
means that the bird’s needs for egg production and growth are covered)
BODYWEIGHT CONTROL
• The birds must be sample weighed weekly from the first week. During the first 4 weeks, collective weights
can be taken in batches of 5 or 10 birds using a bucket. Subsequently, the birds can be weighed
individually.
• From 26 weeks of age, weigh the birds every 2 weeks and then monthly from 35 weeks of age,
• Weigh a sufficient number of birds (around 100) cornered using lightweight screens or frames in 2 or 3
places in the house. For an accurate interpretation of the result, it is important to weigh all the birds
caught in the sample. Weights can be recorded on a weighing sheet which is available from our
technicians. It is good practice to walk the house first to stir the birds up to allow for a more realistic
sample to be penned.
• After weighing, average body weight and uniformity are calculated and immediately plotted on
NOVOGEN growing curve chart. The analysis of the growing curve helps to accurately adjust the feed
allowance (the quantities indicated in our feed section are only to be considered as a guideline) and
when required, to take the appropriate steps to correct the uniformity.
UNIFORMITY CONTROL
• The uniformity target is set to ensure 80 % of the body weights are in a range between + 10 and -10 %
of the flock mean body weight.
• The following factors play an important role in achieving and maintaining good uniformity:
o access to feed and water (see equipment standards)
o health status of the flock
o disease and parasitism
o quality of beak treatment
o temperature and ventilation
16
BEAK TREATMENT
5. BEAK TREATMENT
BEAK TREATMENT MONITORING
• Beak treatment is sometimes undertaken where either light intensity cannot be controlled due to the
design of the house or when other kind of challenges chronically stress out the birds. The beak treatment
procedure is performed to prevent feather pecking and cannibalism under these conditions.
• Beak treatment is a delicate operation and should only be carried-out by well-trained and experienced
operators. Poor beak treatment can affect the ability of the birds to eat and drink correctly and leads to
unevenness. Attention should be paid to local regulations regarding beak treatment and it is advisable
to seek veterinary advice to ensure the procedures are being correctly applied.
• Two different methods can be used for beak treatment. The first one consists of an infrared treatment of
the beak at day-old in the hatchery by using a specific machine. The second method can be practiced at
7-10 days by using a hot blade. With this second method and under some specific conditions, where
permitted, a second beak treatment may be undertaken at 8-10 weeks.
• Before beak treatment with hot blades (in countries where this is permitted):
o check that the birds are healthy
o do not treat the beaks when the birds are reacting to vaccinations
o add vitamin K to the drinking water (to prevent haemorrhaging)
o check that the temperature of the blades is high enough to prevent haemorrhaging, but not too high
which may risk chicks being burned.
• To limit the effect of beak treatment with hot blades on the feed consumption and water intake, it is
important to increase the water level in the drinkers and the pressure in the pipes. Ensure that the depth
of the feed in the feeders is correct.
As outlined above, in addition to the technical recommendations, any local code or regulation concerning animal
welfare should be respected.
Photo: Infra-red beak treatment machine Photo: Pullet with a treated beak
17
BEAK TREATMENT
FULLY BEAKED FLOCKS MANAGEMENT
Photo: Fully beaked pullet
In case of fully beaked flocks, different measures are necessary to prevent the consequences on selective feed intake
and potential damage due to pecking:
• Strictly respect the feeding and drinking spaces and the stocking density standards before starting up. It
will ensure a good uniformity of the flock and avoid risks of competition and fights between the birds.
• Keep the birds calm by avoiding any stress: equipment malfunction, visitors, any sudden changes in the
management (light intensity, number of feed distributions, feed formulation…).
• Provide distractions for the birds to keep them busy: wood shaving pack, oyster shell, plastic strings…
All the toys could help to maintain a good behavior. But layers get used to the toys very quickly, they
need to be changed regularly, each week for example, otherwise, they stop playing with.
• Distribution of grit and grain on the floor can also enhance litter scratching.
• There is a strong relationship between feeding time and pecking, the shorter the feeding time the higher
the risk of pecking. Also, the feed presentation is of high importance. If the particles are too big, it will
reduce the feeding time and increase the risk of feather pecking and feed selection. If they are too fine it
will induce poor appetite.
• Be on the alert for the absence of fluff or small feathers on the floor. It can mean that the birds are eating
the feathers due to a nutrient deficiency in fibre source and it can easily turn into feather pecking. It can
be confirmed by the presence of feather in the intestine. It is sometimes possible to reduce the level of
feather pecking by increasing the fibre content of the feed, particularly insoluble fibres. It is also possible
to add alfalfa or straw on the floor to provide additional fibre for the bird.
• Feed has to be well balanced in energy, amino acid, nutrient, fibre… Any deficiency in the feed can
induce feather pecking.
• Placing some gas concrete blocks in the house as they can help to smoothen the sharp end of the beak
and thereby prevent pecking and selective feed intake.
• It is important to maintain a suitable climate (ventilation, temperature). Hens that feel uncomfortable are
inclined to start feather pecking.
• Special attention has to be given to the lighting. Light intensity and duration are important for preventing
pecking. It is sometimes possible to reduce pecking by dimming or colouring the lights. In dark house, it
is important to avoid any unwanted light source from outside during the night period.
• In production, it is recommended to dim the light a few days after the adaptation in the production house
and to keep the nest in a dark area.
• Respect the health program and avoid parasitic proliferation.
18
WATER MANAGEMENT
6. WATER MANAGEMENT
Water is the first and most important requirement for poultry, it drinks around 1.8 times more than it eats. Therefore,
water management and quality is a priority to ensure optimal flock performances.
WATER MANAGEMENT DURING THE REARING PERIOD

Table: Water management recommendations
Period Advice
• Check the quality of the drinking water and the pipelines.
• Clean and rinse the water pipelines.
Before start up
• Make sure that the water temperature is around 20 to 25ºC.
• Check the nipples.
• Provide unlimited water.
• Keep the water pressure as low as possible. It will help the chicks to find the water
After start up
• Adjust the height of the drinkers according to the chick size and growth. The chicks
must be able to drink without difficulties.
WATER QUANTITY
The ratio water/feed is generally mentioned as being close to 2.0, but in reality it depends more on the environmental
temperature. In a hot temperature climate, this ratio increases as the birds will drink more and eat less. In this
condition, it is recommended to supply cool water to the birds. Water temperature above 20 ºC should be avoided.
Water consumption is an important indicator to follow. Therefore, it is recommended to install a water meter on the
water line. This equipment is inexpensive and easy to install. A low consumption can indicate a shortage of water
supply or a sanitary problem on the flock. Waste of water can also be detected thanks to the water meter.
The below table gives some indication on water consumption according to the environmental temperature (source:
ITAVI, 2012).
Table: Water consumption recommendations according to environmental temperature
Water/Feed ratio Water consumption in
House T ºC
Rearing Production production (ml/bird)
15 1.6 1.7 210

20 1.7 1.8 205
25 2.3 2.1 230
30 3.0 3.1 320
WATER QUALITY
• A water sample for analysis should be taken at the entry point of the house to check the quality of the
water supply, and at the end of the system to check the efficiency of the disinfection system.
• Sample once or twice a year. More samplings should be performed especially when using a local water
supply (surface well, deep well, etc…)
• Clean the pipe system during the sanitary break between flocks.
• Clean drinkers on a regular basis
19
WATER MANAGEMENT
Table: Water quality measures interpretation (ITAVI, 2007)
Criteria Risk
Antibiotic and vaccine loss of efficiency
Reduction of chlorine treatment efficiency
pH > 8
Favours the growth of detrimental Gram negative bacteria
pH
(Salmonella, E. coli, etc...)
(5.5 < pH < 6.5)
Urinary and/or digestive problems
pH < 4 Skeletal weakening
Water system corrosion
Physicochemical recommendations
Reduces solubility of some antibiotics and vitamins

> 20°F Tartar development in the water system, but poultry is quite
Hardness tolerant to high hardness
(10 to 15°F) Trace minerals deficiency and influence on egg shell
< 6°F strength
Water system corrosion
Iron
Iron > 1 mg/l Decrease in water intake
(≤ 0.2 mg/l)
and/or Manganese Reduction in chlorine treatment efficiency
Manganese > 0.15 mg/l Increases bacterial development
(≤ 0.05 mg/l)
Nitrates Digestive troubles at high concentration
> 50 mg/l
(≤ 50 mg/l) Reduces vaccine efficiency
Organic matter
> 5 mg/l Look for source of contamination (water supply, biofilm)
(≤ 2 mg/l)
Nitrites Enhances biofilm development
> 0.1 mg/l
(≤ 0.1 mg/l) Can be toxic at low concentration
Total flora
> 100 germs/ml
recommendations
(≤ 100 germs/ml)
Bacteriological
Faecal germs contamination can be detrimental in itself as

Salmonella a direct source of pathogenic agents (ex: E. coli), but also
> 0 germs/ml
(0 germs/ml) serve as an indicator for other contaminants (like parasites
or viruses)
E. Coli
> 0 germs/ml
(0 germs/ml)
Before starting any water treatment, it is recommended to take advice from a local specialist.
20
WATER MANAGEMENT
Table: Main physicochemical treatments

pH Hardness Iron / Manganese
Mineral acidification: chloride

or sulphuric acid Neutralization Softening
Treatment Iron / Manganese removal
Organic acidification: formic, (water < 10°F) (water > 15°F)
propionic, lactic... acid
pH reduction
Small dose can be enough
Bacteriostatic or bactericidal
action depending on the acid Increase of pH Hardness
Effect Iron / Manganese removal
used and hardness reduction
Potentially positive effect on
digestive system (not for the
mineral acids)
Table: Main antibacterial treatments

Chlorine Chlorine dioxide Hydrogen peroxide
Mixed in the water Mixed in the water
Soluble gas made from the mix
Principle of Free residual chlorine (FRC) is of sodium chlorite and Recommended to be used with
action reacting with bacteria and has chlorehydric acid. The gas is paracetic acid for the pipes
to be measured at the end of injected in the water. cleaning during the flock
the water line. (intermittent treatment)
Initial dosage of 1 to 4 mg/l of
Maximum initial dosage of 1 Initial dosage depends on the
active chlorine
mg/l product concentration
0.3 to 0.6 mg/l of free chlorine
0.3 to 0.5 mg/l of FRC at the 30 to 50 mg/l of hydrogen
at the end of the pipe line. To
end of the pipe line. To check peroxide at the end of the
check every 2 weeks with a
Methods every 2 weeks (reactant DPD). water line.
DPD coloured system.
For a better efficiency, avoid For a better efficiency, avoid
For a better efficiency, avoid
high level of iron, manganese the presence of organic
high level of iron, manganese
and organic matter. No effect matter. No effect of the pH on
and organic matter and a pH >
of the pH on the treatment the treatment
7.5.
Installation
and running -- ++ ++
cost
At the end of the water line with With a colorimetric test: Level of hydrogen peroxide to
Monitoring
a colorimetric test: reactant reactant DPD (level of chlorine be measured with reactive
the efficiency
DPD dioxide = 1.9 free chlorine) strips.
Bacteria (at a concentration of

Efficient Bacteria, fungi, algae, virus Bacteria, fungi, algae, virus
0.2 mg/l at the end of the water
against... and spores. and spores.
line), fungi, algae and virus.
Other existing water disinfection systems: electrolysis, UV sterilization, Copper sulphate…
21
NUTRITION
7. NUTRITION
Some important points :
• All NOVOGEN recommendations are made with a quality protein. That means with a good availability
and digestibility of Amino Acids (A.A.). Any quality degradation (see raw materials chapter in the Novogen
Nutritition Guide) must result in a proportional decrease in the A.A. matrix value in order to avoid any
deficiency that would limit the genetic potential of the animals.
• Any anti-nutritional factors that may alter the bioavailability of A.A. must be controlled, taken into account
in terms of risk and managed accordingly.
• There are many methods of defining available phosphorus, in particular because of the basic reference
which may be different (monocalcium, anhydrous dicalcium, monosodium...). It is therefore necessary to
adjust locally according to the field results.
• These recommendations are given for an average temperature in husbandry between 20 and 22°C, an
optimal breeding and material.
• It is recommended, whenever possible, to formulate feeds in A.A-ratios, on the basis of lysine in order to
avoid any imbalance (causing a greater need and losses due mainly to competition between A.A.).
Pullets Laying hens

Dig. Lysine 100 100
Dig. Methionine 48 / 50 52 / 58
Dig. Methionine+Cystine 76 / 80 85 / 90
Dig. Tryptophan 19 / 20 20 / 22
Dig. Threonine 68 / 74 66 / 74
These ratios are indicated by ranges, they are adjusted according to the observed field performances and the desired
production objectives (typically feather, egg weight, etc.).
• Attention to the cumulative potential enzymatic valuations on A.A., protein and energy (see chapter
enzymes in NOVOGEN nutrition guide).
A minimum total fiber level is recommended for all their positive effects on the digestion and behaviour of
the animals. For cage farms, 3.5% is the minimum. These levels need to be increased and adjusted for alternative
production systems.
22
NUTRITION
EXAMPLE OF DIET SPECIFICATIONS FOR REARING
PERIOD
Starter Grower Pullet / Developer Pre-Lay
0 - 5 weeks 6 - 10 weeks 11 - 15 weeks 16 weeks to 2%
Crumble or
Crumble Coarse Mash Coarse Mash
Mash
EM Kcal / Kg 2900 - 3000 2800 - 2900 2700 - 2800 (1) 2700 - 2750 (1)
EM Kcal / lb 1316 - 1362 1270 - 1316 1225 - 1270 1225 - 1247
% Crude protein 20.0 - 21.0 18.0 - 19.0 16.0 - 17.0 16.0 - 17.0
% Crude fiber - 2.5 - 5.0 5.0 - 6.5 4.0 - 5.5
% Crude fat 3.5 - 5.5 3.0 - 4.5 2.5 - 4.0 2.5 - 4.5
% Tot. Lysine 1.12 0.97 0.75 0.81

% Tot. Methionine 0.51 0.45 0.35 0.41
% Tot. Methio + Cystine 0.86 0.76 0.67 0.70
% Tot. Tryptophan 0.22 0.20 0.17 0.19
% Tot. Threonine 0.77 0.67 0.57 0.59
% Dig. Lysine 1.00 0.86 0.67 0.72

% Dig. Methionine 0.48 0.42 0.33 0.37
% Dig. Meth & Cystine 0.76 0.67 0.58 0.62
% Dig. Tryptophan 0.19 0.17 0.15 0.16
% Dig. Threonine 0.68 0.58 0.48 0.50
% Calcium 1.00 - 1.10 1.00 - 1.10 0.95 - 1.05 2.20 - 2.50

% Available Phosphorus 0.45 - 0.50 0.40 - 0.45 0.37 - 0.40 0.42 - 0.45
% Sodium 0.17 - 0.20 0.16 - 0.18 0.16 - 0.18 0.16 - 0.18
% Chlorine 0.16 - 0.20 0.16 - 0.20 0.16 - 0.20 0.16 - 0.22
% Potassium 0.70 - 0.80 0.65 - 0.80 0.60 - 0.80 0.60 - 0.80
The energy level of the pullet feed 11 - 15 weeks and pre-lay should be equal to that of the laying feed at the beginning of lay.
In hot climates, it is recommended to increase amino acid levels by 5% in order to compensate for lower consumption.
23
NUTRITION
EXAMPLE OF DIET SPECIFICATIONS FROM 2%
PRODUCTION TO 28 WEEKS
Layer 1
Need g/
Ingested quantity (g/d) 100 (1) 105 (1) 110 (1) 115 (1) 120 (1)
bird / day
% Crude protein 19.5 19.5 18.6 17.8 17.0 16.3
% Crude fiber - 3.5 - 6.0
% Crude fat - 2.5 - 5.5
% Tot. Lysine - 0.96 0.91 0.87 0.83 0.80

% Tot. Methionine - 0.49 0.47 0.45 0.43 0.41
% Tot. Methio + Cystine - 0.82 0.78 0.75 0.71 0.68
% Tot. Tryptophan - 0.22 0.21 0.20 0.19 0.18
% Tot. Threonine - 0.69 0.66 0.63 0.60 0.58
% Tot. Isoleucine - 0.85 0.81 0.77 0.74 0.71
% Tot. Valine - 0.90 0.86 0.82 0.78 0.75
% Dig. Lysine 0.85 0.85 0.81 0.77 0.74 0.71

% Dig. Methionine 0.46 0.46 0.44 0.42 0.40 0.38
% Dig. Meth & Cystine 0.73 0.74 0.70 0.67 0.64 0.61
% Dig. Tryptophan 0.19 0.19 0.18 0.17 0.16 0.16
% Dig. Threonine 0.59 0.59 0.56 0.54 0.51 0.49
% Dig. Isoleucine 0.77 0.77 0.73 0.70 0.67 0.64
% Dig. Valine 0.82 0.82 0.78 0.74 0.71 0.68
% Calcium 4.20 4.20 4.00 3.80 3.65 3.50

% Available Phosphorus 0.42 0.42 0.40 0.38 0.37 0.35
% Sodium Min. 0.16 0.16 0.16 0.16 0.16 0.16
% Chlorine Max. 0.22 0.22 0.22 0.22 0.21 0.20
% Linoleic acid (Min.) - 1.30 1.25 1.20 1.15 1.10
The consumption levels listed above correspond to the usual observed consumption after 25 weeks.
For this period, we recommend to increase by 7% protein and amino acids to take into account both the
needs of growth in addition to production needs and secondly, to take account of lower consumption observed
during the beginning of this period.
24
NUTRITION
EXAMPLE OF DIET SPECIFICATIONS FROM 28 TO 45
WEEKS
Layer 2
Need g/
Ingested quantity (g/d) 100 105 110 115 120
bird / day
% Crude protein 18.5 18.5 17.6 16.8 16.1 15.4
% Crude fiber - 3.5 – 6.5
% Crude fat - 2.0 - 4.5
% Tot. Lysine - 0.90 0.86 0.82 0.78 0.75

% Tot. Methionine - 0.46 0.44 0.42 0.40 0.38
% Tot. Tryptophan - 0.21 0.20 0.19 0.18 0.18
% Tot. Threonine - 0.64 0.61 0.58 0.56 0.53
% Tot. Isoleucine - 0.79 0.75 0.72 0.69 0.66
% Tot. Valine - 0.85 0.81 0.77 0.74 0.71
% Dig. Lysine 0.80 0.80 0.76 0.73 0.70 0.67

% Dig. Methionine 0.43 0.43 0.41 0.39 0.37 0.36
% Dig. Meth & Cystine 0.69 0.69 0.66 0.63 0.60 0.58
% Dig. Tryptophan 0.18 0.18 0.17 0.16 0.16 0.15
% Dig. Threonine 0.55 0.55 0.52 0.50 0.48 0.46
% Dig. Isoleucine 0.72 0.72 0.69 0.66 0.63 0.60
% Dig. Valine 0.77 0.77 0.73 0.70 0.67 0.64
% Calcium 4.20 4.20 4.00 3.80 3.65 3.50

% Sodium Min. 0.16 0.16 0.16 0.16 0.16 0.16
% Chlorine Max. 0.24 0.24 0.24 0.24 0.23 0.22
25
NUTRITION
EXAMPLE OF DIET SPECIFICATIONS FROM 45 TO 70
WEEKS
Layer 3
Need g/
bird / day
% Crude protein 18.0 18.0 17.2 16.4 15.7 15.0
% Crude fat - 1.5 - 3.5
% Tot. Lysine - 0.90 0.86 0.82 0.78 0.75

% Tot. Methionine - 0.46 0.44 0.42 0.40 0.38
% Tot. Tryptophan - 0.21 0.20 0.19 0.18 0.18
% Tot. Threonine - 0.64 0.61 0.58 0.56 0.53
% Tot. Isoleucine - 0.79 0.75 0.72 0.69 0.66
% Tot. Valine - 0.85 0.81 0.77 0.74 0.71
% Dig. Lysine 0.80 0.80 0.76 0.73 0.70 0.67

% Dig. Methionine 0.43 0.43 0.41 0.39 0.37 0.36
% Dig. Meth & Cystine 0.69 0.69 0.66 0.63 0.60 0.58
% Dig. Tryptophan 0.18 0.18 0.17 0.16 0.16 0.15
% Dig. Threonine 0.55 0.55 0.52 0.50 0.48 0.46
% Dig. Isoleucine 0.72 0.72 0.69 0.66 0.63 0.60
% Dig. Valine 0.77 0.77 0.73 0.70 0.67 0.64
% Calcium 4.50 4.50 4.30 4.10 3.90 3.75

% Sodium Min. 0.16 0.16 0.16 0.16 0.16 0.16
% Chlorine Max. 0.24 0.24 0.24 0.24 0.23 0.22
26
NUTRITION
EXAMPLE OF DIET SPECIFICATIONS FROM 70 WEEKS
TO DEPLETION
Layer 4
Need g/
bird / day
% Crude protein 17.5 17.5 16.7 15.9 15.2 14.6
% Crude fat - 1.5 - 3.0
% Tot. Lysine - 0.90 0.86 0.82 0.78 0.75

% Tot. Methionine - 0.46 0.44 0.42 0.40 0.38
% Tot. Tryptophan - 0.21 0.20 0.19 0.18 0.18
% Tot. Threonine - 0.64 0.61 0.58 0.56 0.53
% Tot. Isoleucine - 0.79 0.75 0.72 0.69 0.66
% Tot. Valine - 0.85 0.81 0.77 0.74 0.71
% Dig. Lysine 0.80 0.80 0.76 0.73 0.70 0.67

% Dig. Methionine 0.43 0.43 0.41 0.39 0.37 0.36
% Dig. Meth & Cystine 0.69 0.69 0.66 0.63 0.60 0.58
% Dig. Tryptophan 0.18 0.18 0.17 0.16 0.16 0.15
% Dig. Threonine 0.55 0.55 0.52 0.50 0.48 0.46
% Dig. Isoleucine 0.72 0.72 0.69 0.66 0.63 0.60
% Dig. Valine 0.77 0.77 0.73 0.70 0.67 0.64
% Calcium 4.80 4.80 4.60 4.40 4.20 4.00

% Sodium Min. 0.16 0.16 0.16 0.16 0.16 0.16
% Chlorine Max. 0.25 0.25 0.25 0.24 0.23 0.22
27
HEALTH PROGRAMME
8. HEALTH PROGRAMME
It is impossible to devise a health programme to adequately suit all geographic areas. For this reason, it is strongly
recommended to consult a local specialist to establish a prevention programme adapted to the region.
This guide limits its comments to the description of some rules for the use of vaccines and other treatments. To be
successful, respecting these rules is as important as choosing the right products:
• Staff should be properly trained to carry out veterinary operations. It is useful to create a Standard
Operating Procedure Manual, that describes in full details the way to perform each vaccination or
treatment.
• All the necessary equipment (sprayers, syringes, etc.) must be correctly maintained, and checked before
each use.
• Each operation should be planned and supervised by a technically competent person.
• Vaccines and treatments should be stored in appropriate conditions, in suitable quantities considering
the requirements and supply time.
• Report carefully in the flock records the details of all operations: date, time, vaccine batch number, route,
etc.
• Finally, it is useful to have the help of a laboratory in order to anticipate health problems ahead of time
and to assess the efficiency of the :
o control of disinfection, water and feed quality
o serological monitoring
o post mortem examination, routine parasite checks
VACCINATION
The vaccination programme has to be defined and regularly updated with a local veterinarian.
• Vaccine rules:
o Only vaccinate healthy flock
o Always check the conformity of the vaccines with the vaccination programme. In case of doubt,
immediately contact your local veterinarian.
o Keep records of vaccine serial numbers and expiry dates
o Use clean and specific vaccination equipment
• Vaccine preparation:
Live vaccine Inactivated vaccine
• Live vaccines are fragile and should be prepared with • Inactivated vaccines are administered through
care. adjuvants. The adjuvant can shock the birds if injected
• Vaccine storage should be monitored, to make sure it too cold, so it is advised to slowly warm them up
is kept as per manufacturer recommendations before use (25 to 30°C). To ensure quality injection,
(usually between 2 to 6°C). Regularly check the needles should be sterile before use, and changed
temperature of the storage equipment. regularly. A good base number is to change every
• For freeze-dried vaccines, dilute the powder into 1,000 birds, but more importantly make sure that it is
mineral water or with the provided diluent if not damaging the muscle as it would cause
appropriate carefully injected with a syringe. unnecessary pain and be detrimental to the vaccine
• The quality of the water used for live vaccine should up- take.
be checked: no disinfectant, suitable amount of iron,
manganese and magnesium, no organic matter.
28
HEALTH PROGRAMME
Tables: Vaccination methods and description
VACCINATION
GENERAL DESCRIPTION
METHODS
• Do not use disinfectant or chlorine in a period of 48 hours before
vaccination and 24 hours after.
• Check each drinkers condition and cleanliness
• Cut the water around 2 hours before vaccination. It also depends Photo : Drinking water
on the current temperature (one should be more cautious in hot vaccination
climates and use lesser time) installation
• Prepare the vaccine:
- Clean your hands
- Prepare the required volume of water in a clean tank. A good base
number is 15 to 20% of the previous day water consumption.
- Neutralize the residual chlorine with Sodium Thiosulfate
(16g/1000l water) mix and let it act for 10 minutes.
Drinking water
- Mix the solution vaccine + diluent with the neutralized water for 1
minute
• Distribute the vaccine
Photo : Coloured
• Let the birds drink the vaccine solution. It has to be consumed tongue
within 2 hours
• During the distribution, walk among the birds to move them and
stimulate drinking behaviour.
• Once the vaccination solution has been consumed, give water
without chlorine
• To check the proper vaccine take, a water colorant can be used.
More than 90% of the birds should have a coloured tongue after
the distribution.
• It is recommended tospray in the morning and in a calm
atmosphere (avoid feed distribution right after the vaccination and Photo : Spray
dim the light). vaccination
• Gather the birds
• Turn off the ventilation and heating systems to avoid losses due
to evaporation or dispersion
• Preferably use mineral water
Spray • Check the condition and cleanliness of the spraying machine
• Prepare the vaccine and fill up the spraying machine tank with the
solution of vaccine and water
• Spray at 30-40 cm high / Make sure the droplets size is adapted
to the vaccine used / Spray along the whole building length back
and forth/ Do not spray if the birds pills up
• Wait for 5-10 minutes before switching the light, heating and
ventilation systems back on
29
HEALTH PROGRAMME
VACCINATION
GENERAL DESCRIPTION
METHODS
• Use specific vaccination equipment
• Set the syringe at the required dose: the dose corresponds to the dose of vaccine to be
injected or, for mixed vaccine, the sum of the doses of mixed vaccines
Subcutaneous / • Hold the birds by the wings and inject the vaccine at the indicated location
intramuscular • Regularly check the consumed volume of vaccine according to the number of vaccinated
injection birds
• Beware of defusing syringe when the bottle is getting empty
• Regularly check the needle condition
• Comfortable working conditions are the key to a successful vaccination
Photo : Eye drop vaccination
• Prepare the vaccine
• Hold the bird to be vaccinated with the head
tilted to one side
Eye drop
• Drop one drop of vaccine into the eye.
• Be sure the vaccine spreads over the eye
before releasing the bird.
• Use the provided stylet

• Hold the bird on the side and spread the wing
Wing web • The ideal transfixion area is in the wing membrane facing the elbow
• Dip the stylet in the vial and insert it through the wing.
• Avoid damaging the blood vessels.
30
HEALTH PROGRAMME
Tables: Applications of vaccines
(indicative only, check with your local veterinarian)
Basic vaccines applications
Disease Administration methods Application periods
Intramuscular / subcutaneous /
Marek Day-old
in-ovo
Drinking water / Spray /
Newcastle Disease Depending on the local epidemiological context this
Subcutaneous / Intramuscular /
(ND) can start at day 1
in-ovo
Depending on the local epidemiological context and/or
Gumboro Drinking water / in-ovo
quantity of antibodies of maternal origin
Infectious Drinking water / Spray / Depending on the local epidemiological context,
Bronchitis (IB) Subcutaneous / Intramuscular usually at day 1 with regular boosters
Avian
encephalomyelitis Drinking Water / Wing Web Usually around 12 to 14 weeks of age
(AE)
Optional vaccines applications

Disease Administration methods Application periods
Coccidiosis Spray / drinking water Day-old
Infectious Eye drop / Spray / Injection

Depending on the vaccine and the local
Laryngotracheitis (recombinant vaccines) / in-
epidemiological context
(ILT) ovo / Wing web
Fowl Pox Wing Web 8 to 12 weeks
Spray / Eye drop / Depend on local epidemiological context and vaccine

Mycoplasmosis
Subcutaneous / Intramuscular used
Drinking Water / Spray / Usually based on live vaccines 6 weeks apart and a
Salmonella
Intramuscular booster with inactivated 4 weeks before lay
Wing web /Subcutaneous /
Pasteurellosis Depending on local epidemiological context
Intramuscular
Infectious Coryza Subcutaneous / intramuscular Depending on local epidemiological context
Egg Drop
Subcutaneous / Intramuscular Usually inactivated vaccine before lay
Syndrome (EDS)
31
HEALTH PROGRAMME
PARASITES AND INSECTS MONITORING
The below tables give some indications on the main parasites and insects source of troubles in a layer poultry
farm. The treatments have to be defined and regularly updated with a local veterinarian.
Table: Main parasites and insects in layer poultry farm
DESCRIPTIONS SIGNS TREATMENT
- Roundworm that can measure
up to 12 cm
- It is the most common layer - Litter sanitation measures
paraite
Ascaridia galli
- anaemia, intermittent - Strict cleaning and disinfection

- Adult female lays eggs in the diarrhoea, bodyweight loss, egg between two flocks
intestine that pass in the faeces. production decrease, loss of - Chemical treatment:
- Contamination by eggs fertility in males Benzimidazoles, avermectins,
ingestion, the larvae reaches levamisole, etc...
the infectious stage after 2-3
weeks. The adult can live for
one year.
- Threadworm that can measure
up to 8 cm
- Parasite from the digestive
tract located in the oesophagus,
crop, small intestine or caecum - Litter sanitation measures
according to the species. - Young birds are more
Internal parasites
sensitive - Strict cleaning and disinfection

Capilaria
- The eggs pass in the faeces between two flocks

and reach the infectious stage - Bodyweight loss, apathy, egg
production decrease, can lead - Chemical treatment:
within 3-4 weeks Benzimidazoles, avermectins,
to death
- After ingestion, it can produce levamisole, etc...
sever inflammation and
sometimes haemorrhage
- More common problem in
deep litter houses
- Tapeworm that can measure
up to 4 cm.
- Their development cycle
includes an intermediate host
(insect, snails, slugs, beetles, - Litter sanitation measures
- In case of heavy infection:
ants, earthworms, houseflies...). - Strict cleaning and disinfection
Cestodes
bodyweight loss, feed intake

The hens are being infected by between two flocks
decrease specially with young
eating this host. Consequently, - Chemical treatment is usually
birds, egg production decrease
this parasite is uncommon in based on praziquantel
closed house farm.
- Once in the intestine, it
reaches its maturity at around 3
weeks of age.
32
HEALTH PROGRAMME
DESCRIPTIONS SIGNS TREATMENT
- Chemical products:
Organophosphorus based
(phoxim, azametiphos,
- Behaviour modification due to
dichlorvos...)
the disturbance (pecking,
nervousness...) Pyrethroids based (cyfluthrin,
- Blood sucking during night
permethrin...)
periods - Egg production decrease
External parasites
Spinosad based
- Remain hidden in cracks and - Anaemia that can induce
Red Mites
crevices during the light periods. higher mortality and FCR - Natural products:
- About a day after feeding, the increase Silica, sodium bicarbonate,
female lays eggs in cracks and - Blood stains on the egg shell extracts and essential oils of
crevices of the house medicinal and aromatic
- To be detected and treated as
plants...
- Fast increase of population soon as possible to avoid heavy
infection by using specific trap - Cyclic lighting programme
(when allowed)
- Importance of cleaning and
disinfection measures between
two flocks
- Maintain less than 25% water
in the manure (ventilation,
avoid waste of water, proper
- Female can lay up to 1000 broken eggs disposal, regular
eggs and start laying 4 to 8 days removal of the manure)
- Passive agent of pathogens
after mating.
Fly (Musca domestica)
spread (virus, bacteria, - Chemical treatment should

- Egg development is optimum parasites) target both adults
in manure with 40-70% (organophosphates,
- Disturb the hens and reduce
humidity. pyrethroids, carbamates…)
the egg production
- Larvae are feeding on and larvae (cyromazine,
- Flies dropping increase the triflumuron, some
decomposing organic matter
number of second grade eggs organophosphates…)
- Adults can live 2 weeks in
Insects
summer and up to 2 to 3 months - Biocontrol: acaras, beetles,

in winter. natural predators…
- Alternate the active
molecules to limit risks of
resistance
- Female can lay up to 800 eggs - Passive carrier of pathogens - Strict cleaning and
(Marek virus, salmonella, E. disinfection between two flocks
- Larvae burrow into the ground
Darkling eetles
for insulation as they pupate Coli, aspergillus...) - Chemical treatment should

- Penetrate in insulation target adults (preferably on the
- Life cycle (from egg to walls), and the larvae
adulthood) of 2 months to a year equipment causing heavy
damages (preferably on the litter, under
depending on season and the feeding pans and/or
temperature drinkers)
33
GENERAL FARM RULES

9. GENERAL FARM RULES
Ideally, the best rule of management is to have one age and one breed per site to ensure the "all-in, all-out" principle
is followed at all times.
The choice of the site for the farm, including the layout of the houses, must prioritise the elimination of all possible
sources of contamination. Biosecurity protection is reinforced by hygiene controls.
A changing room should be made available at the entrance of the site. It must be used by everybody entering the
farm (incorporating both a shower and a change of clothes).
When the old flock is removed and before the arrival of the new flock, all houses and equipment must be
thoroughly cleaned and disinfected according to strict procedures and protocols. This should be followed by a rest
period of at least 10 days.
34
CLEANING AND DISINFECTION OF POULTRY HOUSES

10. CLEANING AND DISINFECTION OF POULTRY HOUSES
Between each flock, cleaning and disinfection of the houses, their annexes, surroundings and access ways are
essential to ensure the optimal health conditions required for the incoming flock to maximise its profitability.
OPERATIONS PRIOR TO CLEANING

• Water tank, pipes and nipples:
o Empty the complete water system.
o Clean and de-scale the complete system with an acid solution and leave for 6 hours to soak.
o Rinse twice with clean water.
• All the equipment (nests, feeders, drinkers etc.) are removed and stored on a concrete area.
• The entire ventilation system (air inlets and outlets, fans, heating and ventilation ducts if they are present)
and individual radiant or pancake type brooders are brushed and vacuum cleaned.
• Litter is removed.
WASHING
When washing, ensure local regulations regarding wash down water are observed. As a rule, always ensure that the
dirty water is directed towards a pit or suitable internal drain and does not run outside to the house surroundings or
access roads and pathways.
House
• Soak and remove the remaining organic matter
• Apply a bactericidal and fat removing detergent using an appliance capable of dealing with foam
products.
• Some hours after soaking, wash with a high pressure washer (>50kg/cm²) or with hot water, in the
following order:
o Internal roof surfaces, from the top downwards.
o Walls, from the top downwards.
o Finally, pits and concrete floors.
Equipment
• Nests, drinkers and feeding equipment:
o Soak and remove all organic matter.
o Apply a bactericidal and fat removing detergent using an appliance capable of dealing with foam
products.
o Ensure every piece of equipment gets a thorough wash, followed by rinsing.
o Prior to the final rinsing, immerse the removable parts of the nests (perches and nest box bottoms)
for 24 hours in a disinfectant solution.
o Dry on a clean disinfected concrete area (different to that used for washing).
35

PLACING EQUIPMENT BACK INTO THE HOUSE
The vehicles used for this operation must have been carefully washed and sprayed with disinfectant.
DISINFECTION
• Water pipes
o Prepare a highly concentrated chlorine solution (200 ppm) in the water tank.
o Open the tank to fill the pipes with this solution and leave for 24 hours. Afterwards, drain the water
circuit. Do not forget to seal the water tank to protect it from dust.
• House
o House and equipment disinfection is achieved using a homologous bactericidal, virucidal and
fungicidal disinfectant, applied with a hand held or low pressure sprayer or a foam-producing
machine.
o The list of homologous approved disinfectants may vary from one country to another. We
recommend that you consult the relevant local Authorities for a list of approved disinfectants and the
required concentrations when used for poultry applications.
• Feed Storage Silos
o Scrape, brush wash and after drying, fumigate using fungicidal candles following the manufacturer’s
guidelines.
• Heating and ventilation ducts (if they are present)
o Disinfection using fungicidal, virucidal and bactericidal candles following manufacturer’s guidelines.
• House surroundings and road and path access ways.
o Spread a disinfecting product, such as:
 caustic soda (50 to 100 kg/1000 m2).
 or quicklime (400 kg/1000 m2).
SANITARY PRECAUTIONS
Place clean boots and overalls in the changing room. Replenish footbaths with an appropriate disinfectant.
ASSESSING DISINFECTION EFFECTIVENESS

• Visual examination
o Check for dirt stains in the house and on the equipment.
• Bacteriological analysis
o Contact plates or swabs are applied to equipment and to different places in the house. These are
rapidly forwarded to a laboratory for bacteriological assessment following an agreed protocol with
the laboratory.
RODENT CONTROL
Rodents may be vectors of numerous bacterial diseases such as salmonellosis.
Rodent control is often based on the use of toxic baits which generally contain anticoagulants. These are left in places
frequented by the rodents following a site risk assessment. A poorly prepared rodent control programme may give
variable or poor results. We therefore advise using a specialised rodent control service.
36

RESTING PERIOD
This starts only when all the above operations have been achieved and lasts for at least 10 days, in order for the
house to dry properly.
BEFORE THE NEW FLOCK ARRIVES

• 3 days before the new flock arrives, a residual insecticide is sprayed on all surfaces.
• Fresh litter is placed (never use mouldy material) and its surface sprayed with a larvicidal insecticide.
• Equipment is prepared in the brooding area.
• 24 hours before the new flock arrives, the final disinfection is performed by fogging.
• To be careful with disinfection fo vehicles coming to the farm
37
PERFORMANCE TABLES
11. PERFORMANCE TABLES
REARING TABLE
Age Age Female BodyWeight (gr)

Consumption in g/bird
(Week) (Days) Min. Max.
1 0 to 7 10 65 70
2 8 to 14 15 110 120
3 15 to 21 22 180 190
4 21 to 28 31 270 285
5 29 to 35 35 365 385
6 36 to 42 41 470 495
7 43 to 49 45 570 600
8 50 to 56 48 660 695
9 57 to 63 51 750 790
10 64 to 70 53 840 900
11 71 to 77 55 930 990
12 78 to 84 57 1 020 1 090
13 85 to 91 60 1 100 1 170
14 92 to 98 63 1 180 1 245
15 99 to 105 66 1 260 1 330
16 106 to 112 69 1 340 1 415
17 113 to 119 72 1 410 1 490
18 120 to 126 75 1 480 1 560
38
PERFORMANCE TABLES
PRODUCTION TABLE
Weekly
Body Daily Average Cum.
Morta Cum. egg FCR FC
Age Weight Feed Lay Egg Egg
lity Eggs mass (119 days) (119 days)
(min) Intake Weight mass
/HH
Week g g/bird % % /HH g g g kg/kg g/egg
18 1480 83,0 - - - 0,0 0,0 - 0,00 -

19 1550 87,0 15,5 0,1 1 41,6 45,1 45 26,38 1097,3
20 1610 93,0 41,9 0,2 4 45,6 133,5 179 10,30 458,5
21 1655 103,0 65,0 0,3 9 48,6 220,5 399 6,41 299,3
22 1690 107,0 82,6 0,4 14 51,6 297,2 696 4,75 0,2
23 1710 111,0 90,2 0,5 21 53,6 336,6 1 033 3,95 198,1
24 1725 112,0 93,5 0,6 27 55,4 360,2 1 393 3,49 179,3
25 1735 113,0 94,5 0,7 34 56,6 371,8 1 765 3,20 167,6
26 1745 114,0 95,2 0,8 40 57,6 380,9 2 146 3,00 159,8
27 1755 114,0 95,5 0,9 47 58,5 387,6 2 533 2,85 154,1
28 1765 114,0 95,5 1,0 54 59,0 390,5 2 924 2,74 149,8
29 1770 114,0 95,5 1,1 60 59,4 392,7 3 316 2,65 146,4
30 1770 114,0 95,5 1,2 67 59,8 395,0 3 711 2,58 143,7
31 1775 114,0 95,5 1,3 73 60,3 397,9 4 109 2,53 141,6
32 1775 114,0 95,5 1,4 80 60,6 399,4 4 509 2,48 139,7
33 1775 114,0 95,5 1,5 87 60,8 400,4 4 909 2,43 138,2
34 1780 114,0 95,5 1,6 93 61,0 401,3 5 310 2,40 136,8
35 1780 114,0 95,4 1,7 100 61,3 402,4 5 713 2,37 135,7
36 1785 114,0 95,3 1,8 106 61,5 402,9 6 116 2,34 134,7
37 1785 114,0 95,1 1,9 113 61,7 402,9 6 519 2,31 133,9
38 1790 114,0 94,9 2,0 119 61,8 402,3 6 921 2,29 133,1
39 1790 114,0 94,7 2,1 126 61,9 401,7 7 323 2,27 132,4
40 1790 114,0 94,5 2,2 132 62,0 401,1 7 724 2,26 131,9
41 1795 114,0 94,3 2,3 139 62,2 401,1 8 125 2,24 131,4
42 1795 114,0 94,0 2,4 145 62,3 400,1 8 525 2,23 130,9
43 1800 114,0 93,7 2,5 151 62,4 399,0 8 924 2,22 130,5
44 1800 114,0 93,4 2,6 158 62,5 398,0 9 322 2,20 130,2
45 1800 114,0 93,1 2,7 164 62,6 396,9 9 719 2,19 129,9
46 1805 114,0 92,8 2,8 170 62,7 395,9 10 115 2,18 129,6
47 1805 114,0 92,5 2,9 177 62,8 394,8 10 510 2,18 129,4
48 1810 114,0 92,2 3,0 183 62,9 393,8 10 903 2,17 129,2
49 1810 114,0 91,9 3,1 189 63,0 392,7 11 296 2,16 129,0
50 1810 114,0 91,6 3,2 195 63,1 391,7 11 688 2,16 128,9
51 1815 114,0 91,3 3,3 202 63,3 391,2 12 079 2,15 128,8
52 1815 114,0 91,0 3,4 208 63,4 390,1 12 469 2,14 128,7
53 1815 114,0 90,7 3,5 214 63,5 389,1 12 858 2,14 128,6
54 1820 114,0 90,4 3,6 220 63,6 388,0 13 246 2,13 128,5
55 1820 114,0 90,1 3,7 226 63,7 386,6 13 633 2,13 128,4
39
PERFORMANCE TABLES
Weekly
Body Daily Average Cum.
Morta Cum. egg FCR FC
Age Weight Feed Lay Egg Egg
lity Eggs mass (119 days) (119 days)
(min) Intake Weight mass
/HH
Week g g/bird % % /HH g g g kg/kg g/egg
56 1825 114,0 89,8 3,8 232 63,7 385,2 14 018 2,13 128,4
57 1825 114,0 89,5 3,9 238 63,8 383,8 14 402 2,12 128,4
58 1830 114,0 89,2 4,0 244 63,8 382,4 14 784 2,12 128,4
59 1830 114,0 88,8 4,1 250 63,9 380,6 15 165 2,12 128,4
60 1830 114,0 88,4 4,2 256 63,9 378,8 15 544 2,11 128,4
61 1835 114,0 88,0 4,3 262 64,1 377,6 15 921 2,11 128,4
62 1835 114,0 87,6 4,4 268 64,1 375,8 16 297 2,11 128,4
63 1840 114,0 87,2 4,5 274 64,2 374,0 16 671 2,11 128,5
64 1840 114,0 86,8 4,6 279 64,2 372,1 17 043 2,11 128,6
65 1840 114,0 86,3 4,7 285 64,3 369,9 17 413 2,11 128,6
66 1845 114,0 85,8 4,8 291 64,3 367,6 17 781 2,11 128,7
67 1845 114,0 85,3 4,9 297 64,4 365,4 18 146 2,11 128,8
68 1850 114,0 84,8 5,0 302 64,4 363,2 18 509 2,10 128,9
69 1850 114,0 84,3 5,1 308 64,5 360,9 18 870 2,10 129,0
70 1850 114,0 83,8 5,2 313 64,5 358,7 19 229 2,10 129,1
71 1855 114,0 83,3 5,3 319 64,7 357,0 19 586 2,11 129,3
72 1855 114,0 82,8 5,4 324 64,7 354,8 19 940 2,11 129,4
73 1860 114,0 82,3 5,5 330 64,8 352,5 20 293 2,11 129,6
74 1860 114,0 81,8 5,6 335 64,8 350,3 20 643 2,11 129,7
75 1860 114,0 81,3 5,7 341 64,8 348,0 20 991 2,11 129,9
76 1865 114,0 80,8 5,8 346 64,9 345,8 21 337 2,11 130,1
77 1865 114,0 80,3 5,9 351 64,9 343,5 21 681 2,11 130,2
78 1870 114,0 79,8 6,0 356 65,0 341,3 22 022 2,11 130,4
79 1870 114,0 79,2 6,1 362 65,0 338,6 22 361 2,11 130,6
80 1870 114,0 78,6 6,2 367 65,1 336,0 22 697 2,11 130,8
81 1870 114,0 78,0 6,3 372 65,2 333,6 23 030 2,12 131,0
82 1870 114,0 77,4 6,4 377 65,3 331,2 23 361 2,12 131,3
83 1870 114,0 76,8 6,5 382 65,3 328,2 23 689 2,12 131,5
84 1870 114,0 76,2 6,6 387 65,4 325,8 24 015 2,12 131,7
85 1870 114,0 75,6 6,7 392 65,4 322,9 24 338 2,13 132,0
86 1870 114,0 75,0 6,8 397 65,5 320,5 24 659 2,13 132,2
87 1870 114,0 74,4 6,9 402 65,5 317,6 24 976 2,13 132,5
88 1870 114,0 73,8 7,0 407 65,6 315,2 25 291 2,13 132,7
89 1870 114,0 73,2 7,1 411 65,6 312,3 25 604 2,14 133,0
90 1870 114,0 72,6 7,2 416 65,7 309,8 25 914 2,14 133,3
91 1870 114,0 72,0 7,3 421 65,7 307,0 26 221 2,14 133,5
92 1870 114,0 71,4 7,4 425 65,8 304,3 26 525 2,15 133,8
93 1870 114,0 70,8 7,5 430 65,8 301,6 26 826 2,15 134,1
94 1870 114,0 70,2 7,6 434 65,8 299,0 27 125 2,15 134,4
95 1870 114,0 69,6 7,7 439 65,9 296,3 27 422 2,16 134,7
40
Photos © Hélène Réocreux and Marcel Berendsen – V202203
NOVOGEN S.A.S – 5, RUE DES COMPAGNONS – SECTEUR DU VAU BALLIER – 22960 PLEDRAN - FRANCE
Tel. + 33 (0)2 96 58 12 60 - Fax + 33 (0)2 96 58 12 61
[email protected]
www.novogen-layers.com

CS Management Guide Novogen Brown Light GB v3

Uploaded by

Copyright:

Available Formats

CS Management Guide Novogen Brown Light GB v3

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

CS Management Guide Novogen Brown Light GB v3

Uploaded by

Copyright:

Available Formats

Management Guide

NOVOgen Brown Light

9. GENERAL FARM RULES ........................................................................................................................... 34

FLOCK MANAGEMENT DURING THE REARING PERIOD

To achieve those objectives, it is necessary to respect the following basics:

CHOICE OF REARING SYSTEM AND EQUIPMENT

REARING SYSTEM RECOMMENDED PRODUCTION SYSTEM

Photos: Cage rearing system

FLOCK MANAGEMENT DURING THE REARING PERIOD

Photos: Aviary rearing system

FLOCK MANAGEMENT DURING THE REARING PERIOD

FLOCK MANAGEMENT DURING THE REARING PERIOD

 After chicks arrival:

Photos: Control of chicks temperature

Scheme: Chicks distribution example

FLOCK MANAGEMENT DURING THE REARING PERIOD

 LIGHTING PROGRAMME DURING THE FIRST WEEKS OF THE REARING PERIOD

Table: Intermittent lighting programme

• 4 hours light • 8 hours light

 INCREASING DAY LENGTH TO STIMULATE EGG PRODUCTION

 LIGHTING PROGRAMME DURING PRODUCTION

 Light-controlled rearing house to open or semi-dark laying house:

 Open or semi-dark rearing house to light-controlled laying house:

 Open or semi-dark rearing house to open or semi-dark laying house:

18 120 to 126 1410 - 1490 0-2% 13.00 5-15 lux

19 127 to 133 1480-1560 2-25% 14.00 (2) 5-15 lux

NDL: Natural Day Length

18 120 to 126 1410 - 1490 0-2% 12.00 (or NDL)

NDL: Natural Day Length

FLOCK MANAGEMENT DURING THE PRODUCTION PERIOD

LIGHTING PROGRAMME DURING THE PRODUCTION

FLOCK MANAGEMENT DURING THE PRODUCTION PERIOD

MANAGEMENT OF EGG WEIGHT

• Bodyweight at light stimulation (or at sexual maturity).

small medium large very large

<53 g 53-63 g 63-73 g >73 g

MANAGEMENT OF EGG SHELL QUALITY

Photo: Shell strength measure Photo: Shell colour measure

MONITORING BODYWEIGHT AND UNIFORMITY

WATER MANAGEMENT DURING THE REARING PERIOD

15 1.6 1.7 210

Reduces solubility of some antibiotics and vitamins

Faecal germs contamination can be detrimental in itself as

Table: Main physicochemical treatments

Mineral acidification: chloride

Table: Main antibacterial treatments

Bacteria (at a concentration of

Other existing water disinfection systems: electrolysis, UV sterilization, Copper sulphate…

Pullets Laying hens

% Tot. Lysine 1.12 0.97 0.75 0.81

% Dig. Lysine 1.00 0.86 0.67 0.72

% Calcium 1.00 - 1.10 1.00 - 1.10 0.95 - 1.05 2.20 - 2.50

% Tot. Lysine - 0.96 0.91 0.87 0.83 0.80

% Dig. Lysine 0.85 0.85 0.81 0.77 0.74 0.71

% Calcium 4.20 4.20 4.00 3.80 3.65 3.50

% Tot. Lysine - 0.90 0.86 0.82 0.78 0.75

% Dig. Lysine 0.80 0.80 0.76 0.73 0.70 0.67

% Calcium 4.20 4.20 4.00 3.80 3.65 3.50

% Tot. Lysine - 0.90 0.86 0.82 0.78 0.75