Solid State Sensors CSN Series

Closed Loop Current Sensors

CATALOG NUMBER SYSTEM

PLEASE NOTE: This matrix is intended
only to aid you in identifying sensor cata-
log listings. It is not all-inclusive, and must
not be used to form new listings.

Example: CSNA111

CSN Closed Loop Current Sensor

Current Range (Peak/RMS nom.)

FEATURES
1 Current sensing up to 1200 amps
1 Measures AC, DC and impulse
CLOSED LOOP SENSORS
Closed loop current sensors measure
AC, DC and impulse currents over 0-25,
A ±70 A/50 A rms nom.
B ±100 A/50 A rms nom.
C ±90 A/50 A rms nom.
D ±22 A/15 A rms nom.
o m
.c
currents 0-50, 0-100, 0-600 and 0-1200 Amp rang- E ±36 A/25 A rms nom.
1 Lowest cost/performance ratio es. The CSN Series is based on the princi- F ±150 A/100 A rms nom.
1 Rapid response, no overshoot ples of the Hall effect and the null balance J ±600 A/300 A rms nom.

U
1 High overload capacity or zero magnetic flux method (feedback K ±1200 A/500 A rms nom.
1 High level of electrical isolation system). The magnetic flux in the sensor L ±600 A/300 A rms nom.

4
between primary and secondary core is constantly controlled at zero. The M ±1200 A/500 A rms nom.

t
circuits amount of current required to balance P ±90 A/50 A rms nom.
1 Small size and weight zero flux is the measure of the primary R ±200 A/125 A rms nom.

e
current flowing through the conductor, T ±150 A/50 A rms nom.
multiplied by the ratio of the primary to

e
secondary windings. This closed loop Supply Voltage
current is the output from the device and 1 ±15 V

through a resistor.
S h
presents an image of the primary current
reduced by the number of secondary
turns at any time. This current can be
expressed as a voltage by passing it
2 ±13 V
3 ±5 V
4 ±12 V to 18 V
5 ±15 V to 24 V
6 ±12 V to 15 V

t a Coil Characteristics
1 1:1000 turns/90 V @ 70°C

a 2 1:2000 turns/160 V @ 70°C

3 1:2000 turns/130 V @ 70°C

.D
4 1:1000 turns/50 V @ 70°C
5 1:1000 turns/110 V @ 70°C
6 1:1000 turns/30 V @ 70°C
7 1:2000 turns/80 V @ 70°C

w 8 1:2000 turns/25 V @ 70°C

9 1:5000 turns/50 V @ 85°C

w Housing Material
1 Polycarbonate/ABS blend

w
PDFINFO p a g e - 0 6 0

o m
.c
4 U
et
h e
a S
at
.D
w
w
w
60 Honeywell 1 MICRO SWITCH Sensing and Control 1 1-800-537-6945 USA 1 F1-815-235-6847 International 1 1-800-737-3360 Canada
Solid State Sensors CSN Series
Closed Loop Current Sensors
CSNA, CSNB, CSNE SERIES ORDER GUIDE

Current Supply Coil Meas. Meas.

Characteristics
Catalog Range Voltage Currents Resist
Listing Amps VDC ±5% Turns Resistance Nom. (@ Inom)
CSNA111 ±70 ±15 1000 90V @ 70°C 50 mA for 50 A 40 to 130V
CSNB121 ±100 ±15 2000 160V @ 70°C 25 mA for 50 A 40 to 270V
CSNB131 ±100 ±15 2000 130V @ 70°C 25 mA for 50 A 40 to 300V
CSNE151 ±5-36 ±15 1000 110V @ 70°C 25 mA for 25 A 100 to 320V
CSNE381* ±5-36 ±5V 1000 66V @ 70°C 25 mA for 25 A 0 to 84V
CSNH151* ±4-43 ±15V 1000 110V @ 70°C 25 mA for 25 A 100 to 320V
NOTE: Extended temperature range and potting also available.
* Contact the 800 number for more information.
SPECIFICATIONS
Catalog Listing CSNA111 CSNB121 CSNB131 CSNE151
Offset Current @ 25°C, mA max. ±0.20 ±0.10 ±0.10 ±0.10
Temperature Drift, 0 to 70°C, mA ±0.35 typ. ±0.20 typ. ±0.20 typ. ±0.17 typ.
±0.60 max. ±0.30 max. ±0.30 max. ±0.60 max.
Linearity 0.1% 0.1% 0.1% 0.2%
Supply Voltage ±15V ±15V ±15V ±15V
Galvanic Isolation @ 50 Hz/1 min. 2.5 kV rms 5 kV rms
Accuracy ±0.5% of IN (nominal Current) at 25°C
Response Time <1 ms
Bandwidth DC to 150 kHz
Temperature Operating: 0 to 70°C (32 to 150°F) Storage: −25 to 85°C (−13 to 185°F)
Primary Circuit Connection Thru-hole Thru-hole Thru-hole Invasive on 10 pins
Secondary Circuit Connection 3 Pins 3 Pins 3 Pins 3 Pins
Current Drain 10 mA (no load current) + output current (secondary current)
‘‘In-Out’’ Sense Signal To obtain positive measuring current on O/P terminal, current must flow in direction of arrow
Mounting PCB, 3 pins, hole size 0.95 mm PCB, 13 pins

PRIMARY PIN CONNECTIONS FOR CSNE151

Primary Current Output Primary
Primary Nom. IDN Max. ID Current Resistance Primary Pin
Turns (A) (A) (mA) (mV) Connections
1 24 36 25 0.3

2 12 18 24 1.1 Current

3 8 12 24 2.5

4 6 9 24 4.4

5 5 7 25 6.3

WIRING DIAGRAMS
CSNA111/CSNB121/CSNB131 CSNE151

PDFINFO p a g e - 0 6 1

Honeywell 1 MICRO SWITCH Sensing and Control 1 1-800-537-6945 USA 1 F1-815-235-6847 International 1 1-800-737-3360 Canada 61
Solid State Sensors CSN Series
Closed Loop Current Sensors
MOUNTING DIMENSIONS (for reference only)

CSNA111, CSNB121, CSNB131

CSNE151/CSNE381

CSNH151

PDFINFO p a g e - 0 6 2

62 Honeywell 1 MICRO SWITCH Sensing and Control 1 1-800-537-6945 USA 1 F1-815-235-6847 International 1 1-800-737-3360 Canada
Solid State Sensors CSN Series
Closed Loop Current Sensors
CSNJ, CSNK SERIES ORDER GUIDE

Current Supply Coil Characteristics Meas.

Range Voltage Currents Meas.
Catalog Listings Amps VDC ± 5% Turns Resistance Nom. Resist (@ Inom)
CSNJ481 ±600 ±12 to 18 2000 25V @ 70°C 150 mA for 300 A 0 to 70V
CSNJ481-001* ±600 ±12 to 18 2000 25V @ 70°C 150 mA for 300 A 0 to 70V
CSNJ481-002 ±600 ±12 to 18 2000 25V @ 70°C 150 mA for 300 A 0 to 70V
CSNJ481-003* ±600 ±12 to 18 2000 25V @ 70°C 150 mA for 300 A 0 to 70V
CSNK591 ±1200 ±15 to 24 5000 50V @ 70°C 100 mA for 500 A 0 to 130V
CSNK591-001* ±1200 ±15 to 24 5000 50V @ 70°C 100 mA for 500 A 0 to 130V
CSNK591-002 ±1200 ±15 to 24 5000 50V @ 70°C 100 mA for 500 A 0 to 130V
CSNK591-003* ±1200 ±15 to 24 5000 50V @ 70°C 100 mA for 500 A 0 to 130V
*Fitted with busbar

SPECIFICATIONS
Catalog Listings CSNJ481 CSNJ481-002 CSNK591 CSNK591-002
CSNJ481-001 CSNJ481-003 CSNK591-001 CSNK591-003
Offset Current @ 25°C, mA max. ±0.30 ±0.30 ±0.20 ±0.20
Temperature Drift, 0 to 70°C, mA ±0.30 typ. ±0.30 typ. ±0.20 typ. ±0.20 typ.
±0.50 max. ±0.50 max. ±0.30 max. ±0.30 max.
Linearity ±0.1% ±0.1% ±0.1% ±0.1%
Supply Voltage ±12 to ±18V ±12 to ±18V ±15 to ±24V ±15 to ±24V
Galvanic Isolation @ 50 Hz/1 min. 7.5 kV rms 7.5 kV rms 6 kV rms 6 kV rms
Accuracy ±0.5% of IN (nominal Current) at 25°C
Response Time <1 ms
Bandwidth DC to 150 kHz
Operating Temperature −40 to 85°C 0 to 70°C −40 to 85°C 0 to 70°C
(−40 to 185°F) (32 to 158°F (−40 to 185°F) (32 to 158°F)
Storage Temperature −40 to 90°C −25 to 85°C −40 to 90°C −25 to 85°C
(−40 to 194°F) (−13 to 85°F (−40 to 194°F) (−13 to 85°F)
Primary Circuit Connection Thru-hole or busbar Thru-hole or busbar Thru-hole or busbar Thru-hole or busbar
Secondary Circuit Connection 3 pins 3 pins 3 pins 3 pins
Current Drain 14 mA (no load current) + output current 22 mA (24 V) + output current
‘‘In-Out’’ Sense Signal To obtain positive measuring current on O/P terminal, current must flow in direction of arrow

Current
Mounting Faston, 3 pins Push-on (spade), 3 terminals

WIRING DIAGRAM

PDFINFO p a g e - 0 6 3

Honeywell 1 MICRO SWITCH Sensing and Control 1 1-800-537-6945 USA 1 F1-815-235-6847 International 1 1-800-737-3360 Canada 63
Solid State Sensors CSN Series
Closed Loop Current Sensors
MOUNTING DIMENSIONS (for reference only)

CSNJ481

CSNK591

PDFINFO p a g e - 0 6 4

64 Honeywell 1 MICRO SWITCH Sensing and Control 1 1-800-537-6945 USA 1 F1-815-235-6847 International 1 1-800-737-3360 Canada
Solid State Sensors CSN Series
Closed Loop Current Sensors
CSNL, CSNM SERIES ORDER GUIDE

Peak Supply Coil Characteristics Meas.

Current Voltage Currents Meas.
Catalog Listings Range Amps VDC ± 5% Turns Resistance Nom. Resist (@ Inom)
CSNL181 ±600 ±12 to 18 2000 25V @ 70°C 150 mA for 300 A 0 to 70V
CSNM191 ±1000 ±12 to 18 5000 50V @ 70°C 100 mA for 500 A 0 to 120V

SPECIFICATIONS
Catalog Listings CSNL181 CSNM191
Offset Current @ 25°C, mA max. ±0.30 ±0.20
Temperature Drift, 0 to 70°C, mA ±0.30 typ. ±0.20 typ.
±0.50 max. ±0.30 max.
Linearity ±0.1% ±0.1%
Supply Voltage ±12 to ±18V ±12 to ±18V
Galvanic Isolation @ 50 Hz/1 min. 7.5 kV rms 7.5 kV rms
Accuracy ±0.5% of IN (nominal Current) at 25°C
Response Time 500 ns <1 ms
Bandwidth DC to 150 kHz
Operating Temperature −40 to 85°C (−40 to 185°F)
Storage Temperature −40 to 90°C (−40 to 194°F)
Primary Circuit Connection Thru-hole Thru-hole
Secondary Circuit Connection 3 pins 3 pins
Current Drain 14 mA (no load current) + output current
‘‘In-Out’’ Sense Signal To obtain positive measuring current on O/P terminal, current must flow
in direction of arrow
Mounting Faston, 3 pins

WIRING DIAGRAM

Current
PDFINFO p a g e - 0 6 5

Honeywell 1 MICRO SWITCH Sensing and Control 1 1-800-537-6945 USA 1 F1-815-235-6847 International 1 1-800-737-3360 Canada 65
Solid State Sensors CSN Series
Closed Loop Current Sensors
MOUNTING DIMENSIONS (for reference only)

CSNL181

CSNM191

PDFINFO p a g e - 0 6 6

66 Honeywell 1 MICRO SWITCH Sensing and Control 1 1-800-537-6945 USA 1 F1-815-235-6847 International 1 1-800-737-3360 Canada
Solid State Sensors CSN Series
Closed Loop Current Sensors
CSNF, CSNR, CSNP, CSNT SERIES ORDER GUIDE

Peak Supply Coil Characteristics Meas.

Current Voltage Currents Meas.
Catalog Listings Range Amps VDC ± 5% Turns Resistance Nom. Resist (@ Inom)
CSNP661 ±90 ±12 to 15 1000 30V @ 70°C 50 mA for 50 A 50 to 100V
CSNT651 ±150 ±12 to 15 2000 100V @ 70°C 25 mA for 50 A 40 to 75V
CSNF161 ±150 ±12 to 15 1000 30V @ 70°C 100 mA for 100 A 10 to 40V
CSNF151 ±180 ±12 to 15 2000 100V @ 70°C 50 mA for 100 A 10 to 75V
CSNR161 ±200 ±12 to 15 1000 30V @ 70°C 125 mA for 125 A 30 to 40V
CSNR151 ±200 ±12 to 15 2000 100V @ 70°C 62.5 mA for 125 A 10 to 40V
NOTE: Busbar options available.

SPECIFICATIONS
Catalog Listings CSNP661 CSNT651 CSNF161 CSNF151 CSNR161 CSNR151
Offset Current @ 25°C, mA max. ±0.20 ±0.10 ±0.20 ±0.10 ±0.20 ±0.10
Temperature Drift, 0 to 70°C, mA ±0.30 typ. ±0.15 typ. ±0.30 typ. ±0.15 typ. ±0.30 typ. ±0.15 typ.
±0.50 max. ±0.25 max. ±0.50 max. ±0.25 max. ±0.60 max. ±0.30 max.
Linearity ±0.1% ±0.1% ±0.1% ±0.1% ±0.1% ±0.1%
Supply Voltage ±12 to 15V ±12 to 15V ±12 to 15V ±12 to 15V ±12 to 15V ±12 to 15V
Galvanic Isolation @ 50 Hz/1 min. 3 kV rms 3 kV rms 3 kV rms 3 kV rms 3 kV rms 3 kV rms
Accuracy ±0.5% of IN (nominal Current) at 25°C
Response Time <500 ns
Bandwidth DC to 150 kHz
Operating Temperature −40 to 85°C (−40 to 185°F) −40 to 85°C (−40 to 185°F)
Storage Temperature −40 to 90°C (−40 to 194°F) −40 to 90°C (−40 to 194°F)
Primary Circuit Connection Thru-hole
Secondary Circuit Connection 3 pins
Current Drain 10 mA (no load current) +
output current 14 mA (no load current) + output current
‘‘In-Out’’ Sense Signal To obtain positive measuring current on O/P terminal, current must flow in direction of arrow
Mounting 3 pins
Pin Style A A B B B B

Current
WIRING DIAGRAM

PDFINFO p a g e - 0 6 7

Honeywell 1 MICRO SWITCH Sensing and Control 1 1-800-537-6945 USA 1 F1-815-235-6847 International 1 1-800-737-3360 Canada 67
Solid State Sensors CSN Series
Closed Loop Current Sensors
MOUNTING DIMENSIONS (for reference only)

PDFINFO p a g e - 0 6 8

68 Honeywell 1 MICRO SWITCH Sensing and Control 1 1-800-537-6945 USA 1 F1-815-235-6847 International 1 1-800-737-3360 Canada