2007 Yaris

FOREWORD
This wiring diagram manual has been prepared to provide

information on the electrical system of the 2007 YARIS.
na
Applicable models: NCP91, 93 Series
Refer to the following manuals for additional service

specifications and repair procedures for these models:
Manual Name Pub. No.

sic
D 2007 YARIS Repair Manual RM01V0U
D 2007 YARIS New Car Features NM01V0U
All information in this manual is based on the latest product

information at the time of publication. However, specifications
and procedures are subject to change without notice.
oe
lec
NOTICE
Always follow the directions given in the above repair manuals when handling
supplemental restraint system components (such as removal, installation,
inspection, etc.) in order to prevent accidents and supplemental restraint
system malfunction.
.ir
E2006
All rights reserved. This book may not be
reproduced or copied, in whole or in part, without
the written permission of Toyota Motor
Corporation.
First Printing : Feb. 03, 2006 01–060203–00
2007 YARIS
ELECTRICAL WIRING DIAGRAM
Section Code Page
na
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . A . . . . 2
HOW TO USE THIS MANUAL . . . . . . . . . . . . . . . B . . . . 3
TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . C . . . . 12
ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . . . . . D . . . . 17
sic
GLOSSARY OF TERMS AND SYMBOLS . . . . . E . . . . 18
RELAY LOCATIONS . . . . . . . . . . . . . . . . . . . . . . . F . . . . 20
ELECTRICAL WIRING ROUTING . . . . . . . . . . . G . . . . 46
SYSTEM CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . H . . . . 67
oe
GROUND POINT . . . . . . . . . . . . . . . . . . . . . . . . . . . I . . . . 244
POWER SOURCE (Current Flow Chart) . . . . . J . . . . 252
CONNECTOR LIST . . . . . . . . . . . . . . . . . . . . . . . . K . . . . 258
PART NUMBER OF CONNECTORS . . . . . . . . . L . . . . 276

lec
OVERALL ELECTRICAL WIRING DIAGRAM . M . . . . 280
.ir
YARIS (EM01V0U)
A INTRODUCTION
This manual consists of the following 13 sections:
No. Section Description
INDEX Index of the contents of this manual.

na
A
INTRODUCTION Brief explanation of each section.
HOW TO USE THIS

B Instructions on how to use this manual.
MANUAL
TROUBLE–
C Describes the basic inspection procedures for electrical circuits.
SHOOTING
D ABBREVIATIONS Defines the abbreviations used in this manual.

sic
GLOSSARY OF
E TERMS AND Defines the symbols and functions of major parts.
SYMBOLS
Shows position of the Electronic Control Unit, Relays, Relay Block, etc.
F RELAY LOCATIONS
This section is closely related to the system circuit.
ELECTRICAL Describes position of Parts Connectors, Splice points, Ground points, etc.
G
WIRING ROUTING This section is closely related to the system circuit.
INDEX Index of the system circuits.

oe
Electrical circuits of each system are shown from the power supply through ground
H points. Wiring connections and their positions are shown and classified by code
SYSTEM CIRCUITS according to the connection method. (Refer to the section, ”How to use this manual”).
The ”System Outline” and ”Service Hints” useful for troubleshooting are also contained
in this section.
I GROUND POINT Shows ground positions of all parts described in this manual.
POWER SOURCE
J Describes power distribution from the power supply to various electrical loads.
(Current Flow Chart)
lec
Describes the form of the connectors for the parts appeared in this book.
K CONNECTOR LIST
This section is closely related to the system circuit.
PART NUMBER OF
L Indicates the part number of the connectors used in this manual.
CONNECTORS
OVERALL
M ELECTRICAL Provides circuit diagrams showing the circuit connections.
WIRING DIAGRAM
.ir
YARIS (EM01V0U)
HOW TO USE THIS MANUAL B
This manual provides information on the electrical circuits installed on vehicles by

dividing them into a circuit for each system.
na
The actual wiring of each system circuit is shown from the point where the power
source is received from the battery as far as each ground point. (All circuit
diagrams are shown with the switches in the OFF position.)
When troubleshooting any problem, first understand the operation of the circuit
where the problem was detected (see System Circuit section), the power source
supplying power to that circuit (see Power Source section), and the ground points
sic
(see Ground Point section). See the System Outline to understand the circuit
operation.
When the circuit operation is understood, begin troubleshooting of the problem

circuit to isolate the cause. Use Relay Location and Electrical Wiring Routing
sections to find each part, junction block and wiring harness connectors, wiring
harness and wiring harness connectors and ground points of each system circuit.
oe
Internal wiring for each junction block is also provided for better understanding of
connection within a junction block.
Wiring related to each system is indicated in each system circuit by arrows
(from__, to__). When overall connections are required, see the Overall Electrical
Wiring Diagram at the end of this manual.
lec
.ir
YARIS (EM01V0U)
B HOW TO USE THIS MANUAL
* The system shown here is an EXAMPLE ONLY. It is different to the actual
circuit shown in the SYSTEM CIRCUITS SECTION.
[A]
Stop Light
na
[M]
(BAT) (IG)
15A 7.5A
STOP GAUGE
[B] 1 3 IB 4 IB
R–L
W–R
sic
(S/D)
7 3C
L
2
[C] [G]
H6
Stop Lamp SW
14 CH1 15 3C
R–L
(W/G)
(S/D)
R
L
G–W
Combination Meter
4
Skid Control ECU
15 CH1 [E]
Lights
with Actuator
Rear
G–W
[D]
H7
(S/D)
13
L
oe G–W
Y–G
[F]
H4
7 8 Light Failure Sensor 4
2 1 11
G–R
[H]
1
G–R
HJ1 [N]
[I]
W–B
G–B
lec
Rear Combination Lamp (RH)
Rear Combination Lamp (LH)

G–R
G–R
(Shielded)
4 3
2
H17
[J]
Stop
Stop
Center Stop
Lamp
H9
1
J7
3 6
W–B
W–B
W–B
1
W–B
HJ1
.ir
W–B
H1 [K] H2
50 [L]
YARIS (EM01V0U)
B
[A] : System Title [H] : Indicates the wiring color.
[B] : Indicates a Relay Block. No shading is used and Wire colors are indicated by an alphabetical code.
only the Relay Block No. is shown to distinguish it B = Black W = White BR = Brown
from the J/B
L = Blue V = Violet SB = Sky Blue
Example: Indicates Relay Block No.1
na
R = Red G = Green LG = Light Green
[C] : ( ) is used to indicate different wiring and P = Pink Y = Yellow GR = Gray
connector, etc. when the vehicle model, engine
type, or specification is different. O = Orange
The first letter indicates the basic wire color and the
[D] : Indicates related system. second letter indicates the color of the stripe.
[E] : Indicates the code for the (male and female)
connectors which are used to join two wire Example: L–Y
harnesses. The connector code consists of two
alphabetical and one numerical characters.
L Y
sic
(Blue) (Yellow)
[I] : Indicates a shielded cable.
Female Male ( )
The first character of the connector code indicates

the alphabetical code allocated to the wire harness
which has the female connector, and the second [J] : Indicates the pin number of the connector.
shows that of the wire harness which has the male The numbering system is different for female and
connector. male connectors.
The third character indicates a serial number used
to distinguish between the wire harness Example: Numbered in other Numbered in other
combinations in cases when more than one of the from upper left to from upper right to
oe
same combination of wire harnesses exist lower right lower left
(e.g. CH1 and CH2).
Symbol ( ) indicates the male terminal connector.

Numbers outside connector codes indicate the pin Female Male
numbers of both male and female connectors.
[F] : Represents a part (all parts are shown in sky blue). [K] : Indicates the ground point. The code consists of the
The code is the same as the code used in parts two characters: A letter and number.
position. The first character of the code indicates the
alphabetical code allocated to the wire harness.
[G] : Junction Block (The number in the circle is the J/B The second character indicates a serial number
No. and the connector code is shown beside it).
lec
used to distinguish between the ground points in
Junction Blocks are shaded to clearly separate cases when more than one ground point exist on the
them from other parts. same wire harness.
[L] : Page No.
Example: [M] : Indicates the ignition key position(s) when the
power is supplied to the fuse(s).
3C indicates that [N] : Indicates a wiring Splice Point.
it is inside
Junction Block
No.3
Example:
.ir
YARIS (EM01V0U)
[O] System Outline
Current is applied at all times through the STOP fuse to TERMINAL 2 of the stop lamp SW.
When the ignition SW is turned on, current flows from the GAUGE fuse to TERMINAL 8 of the light failure sensor, and also flows
through the rear lights warning light to TERMINAL 4 of the light failure sensor.
Stop Light Disconnection Warning
na
When the ignition SW is turned on and the brake pedal is pressed (Stop lamp SW on), if the stop light circuit is open, the current
flowing from TERMINAL 7 of the light failure sensor to TERMINALS 1, 2 changes, so the light failure sensor detects the
disconnection and the warning circuit of the light failure sensor is activated.
As a result, the current flows from TERMINAL 4 of the light failure sensor to TERMINAL 11 to GROUND and turns the rear lights
warning light on. By pressing the brake pedal, the current flowing to TERMINAL 8 of the light failure sensor keeps the warning
circuit on and holds the warning light on until the ignition SW is turned off.
[P] : Parts Location

Code See Page Code See Page Code See Page
H4 36 H7 36 H17 38
H6 36 H9 38 J7 38
sic
[Q] : Relay Blocks
Code See Page Relay Blocks (Relay Block Location)

1 18 R/B No.1 (Instrument Panel Brace LH)
[R] : Junction Block and Wire Harness Connector
Code See Page Junction Block and Wire Harness (Connector Location)
3C 22 Instrument Panel Wire and J/B No.3 (Instrument Panel Brace LH)
IB 20 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
[S] : Connector Joining Wire Harness and Wire Harness

Code See Page Joining Wire Harness and Wire Harness (Connector Location)
oe
CH1 42 Engine Room Main Wire and Instrument Panel Wire (Left Kick Panel)
HJ1 50 Instrument Panel Wire and Floor Wire (Right Kick Panel)
[T] : Ground Points
Code See Page Ground Points Location

H1 50 Under the Left Center Pillar
H2 50 Back Panel Center
lec
.ir
YARIS (EM01V0U)
B
[O] : Explains the system outline.
[P] : Indicates reference pages showing the parts locations in the system circuit on the vehicle.
na
Example : Code ”H4” (Light Failure Sensor) is on page 36 of the manual.
* The first character of the code indicates the alphabetical code allocated to the wire harness, and the
second character indicates the serial number of the parts connected to the wire harness.
Example : H 4
Á
ÁSerial number for the connected parts
Code for the wire harness
[Q] : Indicates the reference page showing the position on the vehicle of Relay Block Connectors in the system circuit.
Example : Connector ”1” is described on page 18 of this manual and is installed on the left side of the instrument
sic
panel.
[R] : Indicates the reference page showing the position on the vehicle of J/B and Wire Harness in the system circuit.
Example : Connector ”3C” connects the Instrument Panel Wire and J/B No.3. It is described on page 22 of this
manual, and is installed on the instrument panel left side.
[S] : Indicates the reference page describing the wiring harness and wiring harness connector (the female wiring
harness is shown first, followed by the male wiring harness).
Example : Connector ”CH1” connects the Engine Room Main Wire (female) and Instrument Panel Wire (male).
It is described on page 42 of this manual, and is installed on the left side kick panel.
oe
[T] : Indicates the reference page showing the position of the ground points on the vehicle.
Example : Ground point ”H2” is described on page 50 of this manual and is installed on the back panel center.
lec
.ir
YARIS (EM01V0U)
The ground points circuit diagram shows the connections from all major parts to the respective ground points. When
troubleshooting a faulty ground point, checking the system circuits which use a common ground may help you identify
the problem ground quickly. The relationship between ground points ( A1 , A2 and D4 shown below) can also be
checked this way.
na
I GROUND POINT
D43
Junction
H23 Connector
12 9
DLC3 BR BR BR 10 6 (Shielded)
(SG) HB4 DB1
D63
5 BR Throttle
(Shielded)
(Shielded)
(L) Position SW
D60
A20 4 3 BR Injection
sic
W–B 8 (E1) Pump Assembly
Headlamp Leveling
Motor (LH) (LH E)
L5 2 11 BR
W–B 3 W–B 7 (E1)
Power Window
Master SW (E) LA1
1 D2
BR Engine ECU
(E01)
Connector
A22
BR
Junction
Cooling Fan W–B 4
(E)
A25
Motor No.3 BR
(E02)
3
W–B
D4 (5L–E)
A8
Headlamp Leveling W–B
Motor (RH) (RH E)
A5 C2
W–B
Pressure SW W–B W–B Fog Lamp

(–S) (E) (Front LH)
oe
A23 5 C4
Turn Signal Lamp W–B W–B W–B W–B Fog Lamp
(Front LH) (E) CA1 (E) (Front RH)
A11 A10
W–B
Windshield W–B W–B Brake Fluid Level

Wiper Motor (E) (E) Warning SW
I9 12 7 A1
Headlamp W–B W–B W–B W–B Turn Signal Lamp
Leveling SW (E) IH2 HA1 (E) (Front RH)
W–B
A6
Clearance Lamp W–B K5
(Front RH) (E) 3
W–B W–B Power Window
KA1 (E) Master SW
W–B
A21
Clearance Lamp W–B W–B
(Front LH) (E)
20 W – B (Shielded)
lec
A1
W–B
(GND2) 18 W – B (Shielded)
A24
Option Connector
Connector
(Vacuum) W–B
Junction
(GND1)
W–B
B36
21 16
W–B W–B
W–B
(GND) AB1
B19
Skid Control ECU
with Actuator 12 6
W–B W–B W–B
(GND) AB1 AB1
W–B
W–B
W–B
.ir
A2
* The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
YARIS (EM01V0U)
B
The ”Current Flow Chart” section, describes which parts each power source (fuses, fusible links, and circuit breakers)
transmits current to. In the Power Source circuit diagram, the conditions when battery power is supplied to each system
are explained. Since all System Circuit diagrams start from the power source, the power source system must be fully
understood.
na
J POWER SOURCE (Current Flow Chart)
The chart below shows the route by which current flows from the battery to each electrical source
(Fusible Link, Circuit Breaker, Fues, etc.) and other parts
10A ECU–B
Short Pin 2 2
7.5A DOME
15A EFI
Battery 30A AM2 2 Fusible Link Block 6 10A HAZARD

sic
2
20A RADIO NO.1
Starter S2
10A HORN
100A ALT 6 60A ABS 5
Engine Room R/B (See Page 20)

Fuse System Page
ABS 194
ABS and Traction Control 187
20A STOP Cruise Control 180
Electronically Controlled Transmission 166
Multiplex Communication System 210
oe
Cigarette Lighter 214
Combination Meter 230
Headlight 112
10A DOME Interior Light 122
Key Reminder and Seat Belt Warning
Light Auto Turn Off System
Theft Deterrent and Door Lock Control
Power Source
1.25B
B 1 FL MAIN
W
BA1
Battery
lec
50A MAIN 7.5A DOME
B W 7 W W 1 2 R
1 2
2 2 AH1 1 1
7.5A AM1
B W–R 6
1 2
2 2 AH1
W
W–R
15A HAZ–RADIO
1 2 W
2
8 4
AM1
AM2
H8
Ignition SW
ACC
ST1
ST2
IG1
IG2
.ir
2
20A DEFOG
B–Y 1 2 W–R
1 1
∗ The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
YARIS (EM01V0U)
K CONNECTOR LIST
A1 [A] A2 A3 [C]
Black Gray
na
1 2 3 4 1 2 3 4 5 6 7
1 2 3 4
5 6 7 8
[B] [D]
B1 B2
Black Gray
1 2
sic
3 4 5 6
1 2 3 4 5
6 7 8 9 10111213
K CONNECTOR LIST
BA1 Black
[E] BD2 Gray [F]
1 2 3 4 4 3 2 1
1 2 3 4 5 5 4 3 2 1 5 6 7 8 9 10 11 11 10 9 8 7 6 5
6 7 8 9 10 11 12 13 13 12 11 10 9 8 7 6
oe
[A] : Indicates connector to be connected to a part. (The numeral indicates the pin No.)
[B] : Junction Connector

Indicates a connector which is connected to a short terminal.
Junction Connector
Junction connector in this manual include a short terminal which is

connected to a number of wire harnesses. Always perform
lec
inspection with the short terminal installed.
Short Terminal
[C] : Parts Code

The first letter of the code is taken from the first letter of part, and the numbers indicates its order in parts which
start with the same letter.
[D] : Connector Color

Connectors not indicated are milky white in color.
.ir
[E] : Indicates the connector shapes which are used to join wire harnesses.
On Left : Female connector shapes
On Right : Male connector shapes
Numbers indicate pin numbers.
[F] : Indicates connector colors. (Connectors with not indicated colors are white)
10
YARIS (EM01V0U)
B
L PART NUMBER OF CONNECTORS

Code Part Name Part Number Code Part Name Part Number
A1 Turn Signal Lamp (Front RH) 90980–11019 B22 Door Courtesy SW (Front LH) 90980–12470
na
A2 Inlet Air Temp. Sensor 90980–11163 B23 Front Seat Outer Belt (LH) 90980–12253
A3 Air Flow Meter 90980–12292 B24 Blower SW (Rear Heater) 90980–10463
A4 A/C Pressure Sensor 90980–10845 B25 Front Seat Outer Belt (RH) 90980–12253
A5 Pressure SW 90980–10943 B26 Door Courtesy SW (Front RH) 90980–12470
A6 Clearance Lamp (Front RH) 90980–11156 B27 Cooling Fan ECU No.1
90980–10841
A7
[A] Headlamp
[B](RH) 90980–11314
[C] B28 Cooling Fan ECU No.2
A8 Headlamp Leveling Motor (RH) 90980–11016 B29 Water Temp. Sensor (Radiator) 90980–10735
A9 Brake Vacuum Warning SW 90980–11252 B30 Fuel Filter Warning SW 90980–11003
A10 Brake Fluid Level Warning SW 90980–11207 B32 Door Control Relay (LH) 90980–10789
sic
A11 Windshield Washer Motor 90980–11599 B33 Step Lamp (LH) 90980–10121
A12 Airbag Sensor (Front RH) 90980–11856 B34 Junction Connector
A13 Airbag Squib B35 Junction Connector 90980–11398

90980–12490
[A] : Part Code
[B] : Part Name
[C] : Part Number

Toyota Part Number are indicated.
oe
Not all of the above part numbers of the connector are established for the supply.
lec
.ir
11
YARIS (EM01V0U)
C TROUBLESHOOTING
To Ignition SW VOLTAGE CHECK
IG Terminal
(a) Establish conditions in which voltage is present at the check
point.
Example:
Fuse
na
[A] – Ignition SW on
[B] – Ignition SW and SW 1 on
[A] [C] – Ignition SW, SW 1 and Relay on (SW 2 off)
(b) Using a voltmeter, connect the negative lead to a good ground
SW 1 Voltmeter point or negative battery terminal, and the positive lead to the
connector or component terminal.
[B] This check can be done with a test light instead of a voltmeter.
Relay
[C]
sic
SW 2 Solenoid
CONTINUITY AND RESISTANCE CHECK

(a) Disconnect the battery terminal or wire so there is no voltage
between the check points.
Ohmmeter
(b) Contact the two leads of an ohmmeter to each of the check
oe
points.
SW
If the circuit has diodes, reverse the two leads and check
again.
When contacting the negative lead to the diode positive side
and the positive lead to the negative side, there should be
lec
Ohmmeter
continuity.
When contacting the two leads in reverse, there should be no
continuity.
Diode
Digital Type Analog Type (c) Use a volt/ohmmeter with high impedance (10 kΩ/V
minimum) for troubleshooting of the electrical circuit.
.ir
12
YARIS (EM01V0U)
C
To Ignition SW FINDING A SHORT CIRCUIT
IG Terminal
(a) Remove the blown fuse and disconnect all loads of the fuse.
(b) Connect a test light in place of the fuse.
(c) Establish conditions in which the test light comes on.
na
Test Light Fuse Case Example:
[A] – Ignition SW on
Short [A]
[B] – Ignition SW and SW 1 on
[C] – Ignition SW, SW 1 and Relay on (Connect the
Relay) and SW 2 off (or Disconnect SW 2)
SW 1 (d) Disconnect and reconnect the connectors while watching the
test light.
Short [B] The short lies between the connector where the test light
stays lit and the connector where the light goes out.
Disconnect
Disconnect (e) Find the exact location of the short by lightly shaking the
problem wire along the body.
sic
Light Relay
CAUTION:
(a) Do not open the cover or the case of the ECU unless
Short [C] absolutely necessary. (If the IC terminals are touched,
the IC may be destroyed by static electricity.)
(b) When replacing the internal mechanism (ECU part) of
Disconnect
the digital meter, be careful that no part of your body or
clothing comes in contact with the terminals of leads
SW 2 Solenoid from the IC, etc. of the replacement part (spare part).
oe
DISCONNECTION OF MALE AND FEMALE
CONNECTORS
To pull apart the connectors, pull on the connector itself, not
the wire harness.
HINT : Check to see what kind of connector you are
disconnecting before pulling apart.
lec
Pull Up Pull Up
Press Down Press Down

.ir
13
YARIS (EM01V0U)
C TROUBLESHOOTING
Reference: HOW TO REPLACE TERMINAL
(with terminal retainer or secondary locking device)
10 1. PREPARE THE SPECIAL TOOL
3 1
na
HINT : To remove the terminal from the connector, please
construct and use the special tool or like object shown on
the left.
2. DISCONNECT CONNECTOR
0.2
1 (mm)
Example: Up 3. DISENGAGE THE SECONDARY LOCKING DEVICE OR

Tool
(Case 1)
TERMINAL RETAINER.
(a) Locking device must be disengaged before the terminal

sic
locking clip can be released and the terminal removed from
the connector.
(b) Use a special tool or the terminal pick to unlock the secondary
locking device or terminal retainer.
NOTICE:
Terminal Retainer Do not remove the terminal retainer from connector body.
[A] For Non–Waterproof Type Connector

Terminal Retainer
HINT : The needle insertion position varies according to the

connector’s shape (number of terminals etc.), so
oe
check the position before inserting it.
”Case 1”
[Retainer at Full Lock Position] Raise the terminal retainer up to the temporary lock
position.
Terminal
Stopper Retainer
lec
[Retainer at Temporary Lock Position]
Example: Secondary ”Case 2”

(Case 2) Locking Device
Open the secondary locking device.
.ir
14
YARIS (EM01V0U)
C
Tool
Tab
na
Tab
Example: [B] For Waterproof Type Connector

Terminal
(Case 1) Retainer Tool
HINT : Terminal retainer color is different
according to connector body.
sic
Example:
Terminal Retainer : Connector Body
Black or White : Gray
Black or White : Dark Gray
Tool Access Hole Gray or White : Black
[Male] ( Mark) [Female]
”Case 1”
Type where terminal retainer is pulled
up to the temporary lock position (Pull
Type).
oe
Insert the special tool into the terminal
retainer access hole (YMark) and pull
the terminal retainer up to the
temporary lock position.
Retainer
at Full Lock Position HINT : The needle insertion position varies
according to the connector’s shape
(Number of terminals etc.), so check
the position before inserting it.
lec
Retainer
at Temporary Lock Position
[Male] [Female]
Example: Terminal Retainer ”Case 2”

(Case 2) Type which cannot be pulled as far as
Power Lock insert the tool straight into
the access hole of terminal retainer as
.ir
shown.
Tool Tool
Press Down
[Male] Press Down [Female]
15
YARIS (EM01V0U)
C TROUBLESHOOTING
Push the terminal retainer down to the temporary lock position.
na
Retainer at
Full Lock Position
sic
Retainer at
Temporary Lock Position
[Male] [Female]
Locking Lug (c) Release the locking lug from terminal and pull the terminal out
from rear.
oe
Tool
4. INSTALL TERMINAL TO CONNECTOR
(a) Insert the terminal.

lec
HINT:
1. Make sure the terminal is positioned correctly.
2. Insert the terminal until the locking lug locks firmly.
3. Insert the terminal with terminal retainer in the temporary lock
position.
(b) Push the secondary locking device or terminal retainer in to

the full lock position.
5. CONNECT CONNECTOR
.ir
16
YARIS (EM01V0U)
ABBREVIATIONS D
ABBREVIATIONS
The following abbreviations are used in this manual.
na
A/C = Air Conditioning
A/T = Automatic Transaxle
ABS = Anti–Lock Brake System
CAN = Controller Area Network
CPU = Central Processing Unit
EBD = Electronic Brake Force Distribution

sic
ECU = Electronic Control Unit
EPS = Electric Motor Power Steering
H/B = Hatchback Type
IC = Integrated Circuit
J/B = Junction Block

oe
LED = Light Emitting Diode
LH = Left–Hand
M/T = Manual Transaxle
PTC = Positive Temperature Coefficient
R/B = Relay Block

lec
RH = Right–Hand
S/D = Sedan Type
SRS = Supplemental Restraint System
SW = Switch
TEMP. = Temperature
VSV = Vacuum Switching Valve

.ir
w/ = With
w/o = Without
∗ The titles given inside the components are the names of the terminals (terminal codes) and are not treated as being
abbreviations.
17
YARIS (EM01V0U)
E GLOSSARY OF TERMS AND SYMBOLS
BATTERY GROUND
Stores chemical energy and The point at which wiring attaches to
converts it into electrical energy. the Body, thereby providing a return
Provides DC current for the auto’s path for an electrical circuit; without a
various electrical circuits. ground, current cannot flow.
na
CAPACITOR (Condenser) HEADLIGHTS
A small holding unit for temporary Current flow causes a headlight
1. SINGLE
storage of electrical voltage. FILAMENT filament to heat up and emit light. A
headlight may have either a single
(1) filament or a double (2) filament
CIGARETTE LIGHTER
An electric resistance heating 2. DOUBLE
FILAMENT
element.
sic
CIRCUIT BREAKER HORN
Basically a reusable fuse, a circuit An electric device which sounds a
breaker will heat and open if too loud audible signal.
much current flows through it.
Some units automatically reset when
cool, others must be manually reset.
DIODE IGNITION COIL
A semiconductor which allows Converts low–voltage DC current
current flow in only one direction. into high–voltage ignition current for
firing the spark plugs.
oe
DIODE, ZENER LIGHT
A diode which allows current flow in one Current flow through a filament
direction but blocks reverse flow only up causes the filament to heat up and
to a specific voltage. Above that potential,
emit light.
it passes the excess voltage. This acts as
a simple voltage regulator.
PHOTODIODE LED (LIGHT EMITTING DIODE)

The photodiode is a semiconductor Upon current flow, these diodes emit
which controls the current flow light without producing the heat of a
according to the amount of light. comparable light.
lec
DISTRIBUTOR, IIA METER, ANALOG
Channels high–voltage current from Current flow activates a magnetic
the ignition coil to the individual coil which causes a needle to move,
spark plugs. thereby providing a relative display
against a background calibration.
FUSE METER, DIGITAL

A thin metal strip which burns through Current flow activates one or many
when too much current flows through it, FUEL
LED’s, LCD’s, or fluorescent
thereby stopping current flow and displays, which provide a relative or
protecting a circuit from damage. digital display.
FUSIBLE LINK
.ir
(for Medium Current Fuse) A heavy–gauge wire placed in high
MOTOR
amperage circuits which burns through on
overloads, thereby protecting the circuit.
A power unit which converts
The numbers indicate the crosssection M electrical energy into mechanical
surface area of the wires. energy, especially rotary motion.
(for High Current Fuse or
Fusible Link)
18
YARIS (EM01V0U)
E
RELAY SPEAKER
Basically, an electrically operated An electromechanical device which
1. NORMALLYswitch which may be normally creates sound waves from current
CLOSED closed (1) or open (2). flow.
Current flow through a small coil
na
creates a magnetic field which either
opens or closes an attached switch.
2. NORMALLY SWITCH, MANUAL
OPEN Opens and closes
circuits, thereby
1. NORMALLY
OPEN stopping (1) or
allowing (2) current
flow.
RELAY, DOUBLE THROW
A relay which passes current 2. NORMALLY
through one set of contacts or the CLOSED
other.
sic
RESISTOR SWITCH, DOUBLE THROW
An electrical component with a fixed A switch which continuously passes
resistance, placed in a circuit to current through one set of contacts
reduce voltage to a specific value. or the other.
RESISTOR, TAPPED SWITCH, IGNITION

A resistor which supplies two or A key operated switch with several
more different non adjustable positions which allows various
resistance values. circuits, particularly the primary
ignition circuit, to become
operational.
oe
RESISTOR, VARIABLE or RHEOSTAT
A controllable resistor with a variable
rate of resistance.
Also called a potentiometer or
rheostat.
SENSOR (Thermistor) SWITCH, WIPER PARK

A resistor which varies its resistance Automatically returns wipers to the
with temperature. stop position when the wiper switch
is turned off.
lec
SENSOR, SPEED TRANSISTOR
Uses magnetic impulses to open A solidstate device typically used as
and close a switch to create a signal an electronic relay; stops or passes
for activation of other components. current depending on the voltage
(Reed Switch Type)
applied at ”base”.
SHORT PIN
WIRES
Used to provide an unbroken
Wires are always drawn as
connection within a junction block. (1) NOT straight lines on wiring
CONNECTED diagrams.
Crossed wires (1) without a
black dot at the junction are
.ir
SOLENOID not joined;
An electromagnetic coil which forms crossed wires (2) with a
a magnetic field when current flows, (2) SPLICED black dot or octagonal ( )
to move a plunger, etc. mark at the junction are
spliced (joined)
connections.
19
YARIS (EM01V0U)
F RELAY LOCATIONS
[Engine Compartment]
(H/B)
Engine Control Module Fusible Link Block Skid Control ECU with Actuator
na
Engine Room R/B
Engine Room J/B
Engine Room
R/B No.2
sic
oe
(S/D)
Engine Control Module Fusible Link Block Skid Control ECU with Actuator
Engine Room R/B

Engine Room J/B
lec
Engine Room
R/B No.2
.ir
20
YARIS (EM01V0U)
F
[Instrument Panel]
(H/B)
Power Steering ECU Transponder Key ECU Theft Warning ECU
na
Front Fog Light
Relay
Fuse Block
Running Light
Relay
ACC Cut
Relay J/B No.6
sic
Main Body
ECU
Instrument
Panel J/B Shift Lock
Control ECU
Transponder Key Airbag Sensor

J/B No.5 Amplifier A/C Amplifier Assembly Center
oe
(S/D)
Power Steering ECU Transponder Key ECU Theft Warning ECU
lec
Fuse Block
Running Light
Relay
ACC Cut
Relay J/B No.6
Main Body
ECU
Instrument
Panel J/B Shift Lock
Control ECU
Front Fog
.ir
Light Relay
Transponder Key Airbag Sensor

J/B No.5 Amplifier A/C Amplifier Assembly Center
21
YARIS (EM01V0U)
F RELAY LOCATIONS
[Body]
(5–Door)
Occupant Classification ECU
na
sic
Door Control Receiver
oe
(3–Door)
lec
.ir
22
YARIS (EM01V0U)
F
(4–Door)
na
sic
Occupant Classification ECU Door Control Receiver
oe
lec
.ir
23
YARIS (EM01V0U)
F RELAY LOCATIONS
1 : Engine Room R/B
Engine Compartment Left (See Page 20)
: Engine Room J/B
* 1:H-LP LH/H-LP LO LH
* 2:H-LP RH/H-LP LO RH
na
* 3:30A HTR SUB1 (for High Current)
* 4:30A RDI (for High Current)
* 5:40A HTR (for High Current)
* 6:50A ABS1/VSC1 (for High Current)
* 7:50A EPS (for High Current)
* 8:40A HTR SUB2 (for High Current)
* 9:FAN NO.2 Relay
* 10:ST Relay
sic
ABS2/VSC2
2 30A 1
1
5 3 HTR SUB1
*10 *9 *3 2 Relay
2 1 2 4 1 1 2 *1
2 10A 1
5 5 *4 *2
EFI
3 3 2 10A 1
Unit A 1 20A 2 1 2
*5
1 2
HAZ
oe
2 10A 1
2 10A 1
*6
EFI2
HORN ECTS
1 10A 2 2 10A 1
1 2
ALT-S
2 7.5A 1
*7
ECU-B
2 7.5A 1
1 2
DOME
2 15A 1
*8
AM2
1 15A 2 1 2
ST
2 30A 1
lec
1E 1D
1 1
(from Engine Room (from Engine Room

Main Wire) Main Wire)
Wire Color : B Wire Color : W
Unit B
.ir
24
YARIS (EM01V0U)
F
na
sic
1
2
3
4
1
2
1A 5
3 6
4 7
oe
8
5
6
7 (from Engine Room
8 Main Wire)
1
2
1 3
2
1B 4
3
4 5
6
5 7
6 8
7
8
(from Engine Room
Main Wire)
1C
lec
1
1
(from Engine Room

Main Wire)
Unit A
.ir
25
YARIS (EM01V0U)
F RELAY LOCATIONS
[Engine Room R/B and Engine Room J/B Inner Circuit]
na
Unit A 1 1A
EFI Relay
1 2
4 1A
20A EFI
sic
3 1A
2 1A
5 1A
HORN Relay
1 2
8 1A
10A HORN
7 1A
6 1A
oe
1 1B
IG2 Relay
1 2
4 1B
15A AM2
3 1B
2 1B
lec
5 1B
FAN NO.1 Relay
8 1B
7 1B
6 1B
1 1C
.ir
26
YARIS (EM01V0U)
F
na
1 2
1
Unit B 30A ABS2/VSC2
1 2
1
30A HTR SUB1
1 2
1
sic
30A RDI
1 2
1
40A HTR
1 2
1
50A ABS1/VSC1
1 2
1
50A EPS
1 2
1 1E 1
40A HTR SUB2
1 2
oe
1
10A H-LP LH/H-LP LO LH
1 2
1
10A H-LP RH/H-LP LO RH
1 2
1
10A HAZ
1 2
1
10A ETCS
1 2
1
7.5A ALT-S
1 2
1
lec
7.5A ECU-B
1 2
1
15A DOME
1 2
1 1D 1
30A ST
.ir
27
YARIS (EM01V0U)
F RELAY LOCATIONS
2 : Engine Room R/B No.2 Engine Compartment Right (See Page 20)
na
sic
HTR SUB2 Relay H-LP/AMT Relay
2 1
oe
2
5
3 3 5
3
5
1
1 2
lec
HTR SUB3 Relay
.ir
28
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
29
YARIS (EM01V0U)
F RELAY LOCATIONS
: Instrument Panel J/B Lower Finish Panel (See Page 21)
na
141312 1110 9 8 16151413121110 9
7 6 5 4 3 2 1 8 7 6 5 4 3 2 1
19 1
20 2
21 3
22 4
23 5 4B (from Instrument (from Instrument
24 6 Panel Wire) Panel Wire)
25 7 9 18
26 8
8 17
7 16
27 9 4D 4C 6 15
28 10 5 14
29 11 4 13
sic
30 12 3 12
2 11
31 13 1 10
32 14
33 15 (from Instrument
1 16 1 19
34 16
2 17 2 20 7654321
Panel Wire)
35 17 3 18 3 21 87654321
36 18 4 22 1413121110 9 8 16151413121110 9
4 19 5 23
5 20 6 24
4H
6 21 7 25
7 22 8 26
(from Engine Room
Main Wire) 18 9 1 17
8 23 9 27
9 24 10 28 17 8 2 18 17 1
16 7 3 19 18 2
10 25 11 29 4 20 19 3
16 1 11 26 12 30 15 6 5 21
17 2 4A 14 5 6 22
20
21
4
5
18 3 13 4 7 23 22 6
19 4 12 27 13 31 12 3 8 24 23 7
20 5 13 28 14 32 11 2 24 8
21 6 14 29 15 33 10 1 9 25
22 7 15 30 16 34 10 26
4E 25 9
17 35 11 27 26 10
23 8 18 36 12 28 27 11
oe
24 9 4 28 12
25 10 3
26 11 1 3 2 13 29
1 14 30 29 13
4
1 15 31 30 14
27 12 5 16 32 31 15
28 13 2 6 32 16
2
29 14
30 15
2 (from Instrument
3 2 1 Panel Wire)
(from Floor Wire) 1
1
1 8 7 6 5 4
4J 4
3
3 1
4
4K 1 1 2
8 7 6 5 4 1
5
6 2 5 3 5 4 3 3 2 1
(from Instrument
lec
(from Roof Wire) 2 2
Panel Wire)
30A POWER
(for High Current)
1 2 3
4F
4 5 6 7 8
30A DEF
(for High Current)
(from Instrument
Panel Wire)
4L 4G
IG 1 Relay 1 HTR Relay 1 FLASH Relay
(from Engine Room

Main Wire) (from Engine Room
Main Wire)
.ir
30
YARIS (EM01V0U)
F
na
sic
1
2
3
4
5
6
7
8
9
10
11
Main Body ECU 12
13
14
15
16
oe
17
18
19
20
21
22
23
24
25
26
4M 7 8 9 10 1112 10 11121314 151617 18 6 7 8 9 10 6 7 8 9 10 111213 4Q 13121110 9 8 7 6

12 1110 9 8 7 1 2 3 4 5 6 1 2 3 4 5
1 2 3 4 5 6 7 8 9 1 2 3 4 5 54 321
6 5 4 3 2 1
(from Instrument
lec
(from Instrument Panel Wire)
Panel Wire)
4S 4P
123456789 1 2 3 4 5
6 7 8 9 10
101112131415161718
(from Instrument (from Instrument

Panel Wire) Panel Wire)
.ir
31
YARIS (EM01V0U)
F RELAY LOCATIONS
: Instrument Panel J/B Lower Finish Panel (See Page 21)
na
* 1:10A TAIL (H/B, S/D *3)
7.5A PANEL 2 (*4)
* 2:10A TAIL (*4)
* 3:Cold Area Spec., w/ Engine Immobiliser
System, w/ ABS, w/ Rear Window Defogger,
w/ Door Lock Control,
w/ Daytime Running Light,
w/ Remote Control Mirror,
w/ Air Conditioning
sic
* 4:Except H/B, S/D *3
ID/UP/MIR HTR
RR DOOR
RL DOOR
PANEL1
oe
ACC
MET
7.5A
7.5A
7.5A
7.5A
7.5A
20A
20A
15A
CIG
10A
IGN
A/C
*1
FR FOG
RR WIP
GAUGE
ECU-IG
OBD2
STOP
WSH
7.5A
AM1
WIP
25A
15A
15A
10A
10A
10A
25A
15A
25A
D/L
*2
lec
.ir
32
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
33
YARIS (EM01V0U)
F RELAY LOCATIONS
[Instrument Panel J/B Inner Circuit]
* 1:H/B, S/D *3
* 2:Except *1
na
* 3:Cold Area Spec., w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger,
w/ Door Lock Control, w/ Daytime Running Light, w/ Remote Control Mirror, w/ Air Conditioning
10 4A
29 4A
15 4B
T-LP Relay 7.5A PANEL2 (*2) 33 4B
10A TAIL (*1)
1 4G 10 4E
(*1) (*1)
15 4E 7.5A PANEL1
6 4P
sic
3 4E (*1)
2 4Q
9 4S
(*1) 7 4P
13 4B
8 4Q
8 4S
8 4P
7 4C
9 4P
3 4P
6 4Q
4 4P
10 4P
5 4P
9 4Q
5 4K
7 4Q
12 4B
18 4S
oe
17 4A
24 4E PWR Relay 2 4H
1 2
21 4B 11 4H
30A POWER
9 4A
1 4A
12 4A 20A RL DOOR
25 4B 19 4A
20A RR DOOR
4 4E 10 4H
12 4C 6 4K
3 4J 10A ID/UP/MIR HTR
DEF Relay 11 4M
17 4B 1 2
lec
2 4F
35 4B
30A DEF
12 4Q 4 4Q
10A TAIL
4 4M
(*2) (*2)
13 4Q
23 4B 25A D/L
2 4J
8 4E
13 4E 2 4A
12 4D 25A AM1
1 4F
.ir
(Cont. Next Page)
34
YARIS (EM01V0U)
F
na
(Cont'd)
30 4E
10A STOP
14 4E 18 4B
17 4E 7.5A OBD2
5 4S
28 4E
2 4M
12 4E
sic
8 4M
7 4M
6 4M
1 4K
15A FR FOG
15 4A 9 4M
1 4S 5 4M
2 4E
4
3 5
7 4F 1 4L
1 2
5 4Q 10 4B
31 4B HTR Relay 6 4D
16 4S 15 4S
oe
2 LR IG 1
28 4A 19 4B
4 +B EL 5
32 4B 11 4S
6 ER LL 3
12 4S 27 4A
8 7
17 4S EHW GND 14 4B
5 4D 13 4S
FLASH Relay
19 4E
11 4C
7 4S
1 4C Noise Filter
24 4B
9 4C 5 3 10A ECU-IG
3 4K
lec
13 4A
2 1 22 4B
3 4F
30 4A
IG 1 Relay
36 4B 23 4E
25A WIP
1 4H 20 4E
14 4S
15A WSH
2 4B 32 4E
10 4D
10A GAUGE
2 4P
1 4P
.ir
(Cont. Next Page)
35
YARIS (EM01V0U)
F RELAY LOCATIONS
[Instrument Panel J/B Inner Circuit]
na
(Cont'd)
15A RR WIP
25 4A
11 4Q
10 4Q
1 4Q
29 4B
sic
10 4S
7.5A A/C
10 4M
8 4F
25 4E
1 4J C/OPN Relay
11 4B 8 4A
1 4D 5 4E
9 4B
15 4C
21 4E
7.5A IGN
oe
27 4B 4 4F
16 4E
7.5A MET
1 4M
12 4M 5 4F
15A CIG
3 4Q
7.5A ACC
4 4S
6 4S
14 4D
lec
.ir
(Cont. Next Page)
36
YARIS (EM01V0U)
F
na
(Cont'd)
9 4E
4 4K
16 4C
21 19 13 25 1 4 5
34 4B
ACC TRLY PWS HAZ GND1 ALTB IG
16 4B
sic
4 4J 14 4C
20
10 4C PCTY 24 4A
14 4H 6 4C
10 26
5 4H UL1 DCTY 21 4A
2 4K 26 4E
7
27 4E ILE 5 4A
22
11 4E RRCY 20 4A
13 4H 2 4S
12
4 4H L1 30 4B
3 4A Main Body ECU 12 4H
6
17 4H BECU
oe
3 4D
2
8 4H ACT+ 18 4E
15
8 4C HORN 28 4B
8 4D 7 4D
26 4B 6 4E
9
4 4D KSW 4 4C
2 4D 15 4H
2 4C 6 4H
24 16
5 4C PKB UL2 22 4A
9 4D 18 4H
lec
23
7 4A BCTY (H/B) 9 4H
LGCY (S/D) 3
1 4E ACT- 4 4A
7 4E 18 4A
3 4S 16 4H
14
31 4E L2 7 4H
.ir
37
YARIS (EM01V0U)
F RELAY LOCATIONS
: J/B No.5 Left Kick Panel (See Page 21)
na
sic
D1
2 6 6 2
5 5B 5
4 4
oe
1 3 3 1
(from Front Door LH Wire)

1 3 3 1
5A
4 4
5 5
2 6 6 2

lec
.ir
38
YARIS (EM01V0U)
F
[J/B No.5 Inner Circuit]
na
sic
1 5A 1 5B
2 5A 2 5B
3 5A 3 5B
oe
4 5A 4 5B
5 5A 5 5B
6 5A 6 5B
lec
D1
.ir
39
YARIS (EM01V0U)
F RELAY LOCATIONS
: J/B No.6 Right Kick Panel (See Page 21)
na
sic
D2
2 6 6 2
5 6B 5
4 4
oe
1 3 3 1
(from Front Door RH Wire)

1 3 3 1
6A
4 4
5 5
2 6 6 2

lec
.ir
40
YARIS (EM01V0U)
F
[J/B No.6 Inner Circuit]
na
sic
1 6A 1 6B
2 6A 2 6B
3 6A 3 6B
oe
4 6A 4 6B
5 6A 5 6B
6 6A 6 6B
lec
D2
.ir
41
YARIS (EM01V0U)
F RELAY LOCATIONS
Fusible Link Block Near the Battery (See Page 20)
na
sic
Battery
120A ALT
60A MAIN (for High Current)
oe
(for High Current)
C30
1
lec
(from Engine Wire)
Wire Color : B
.ir
42
YARIS (EM01V0U)
F
na
sic
Battery
oe
A28 A27
Black
1 1 2 1
1 2
(from Engine Room (from Engine Room

Main Wire) Main Wire)
lec
.ir
43
YARIS (EM01V0U)
F RELAY LOCATIONS
[Fusible Link Block Inner Circuit]
na
sic
A27(B), A28(A), C30(C)
Fusible Link Block
1
C
oe
1
A
1
Battery B
120A ALT
2
B
60A MAIN
lec
.ir
44
YARIS (EM01V0U)
F
Fuse Block Near the Instrument Panel J/B (See Page 21)
na
sic
oe
ACC2
1 7.5A 2
lec
.ir
45
YARIS (EM01V0U)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[H/B]
A21 A3 A23 A28 A27 A10 A9
na
A1
A2
A7
A11
B1
B8
B4
A15
B3
sic
B13
B11
B6
A6
A25
A4
B12
A22
B7
A5
A24
B9
oe
A18 A8 B5 B2 A12 A14 B10
A 1 Turn Signal Lamp (Front Side RH) B 1 Turn Signal Lamp (Front RH)
A 2 Turn Signal Lamp (Front Side LH) B 2 Horn
A 3 A/C Pressure Sensor B 3 Parking Lamp (RH)
A 4 Rear Washer Motor B 4 Headlamp (RH)
A 5 Windshield Washer Motor B 5 Ambient Temp. Sensor
A 6 Airbag Sensor (Front RH) B 6 Headlamp (LH)
lec
A 7 Speed Sensor (Front RH) B 7 Parking Lamp (LH)
A 8 Cooling Fan Motor B 8 Turn Signal Lamp (Front LH)
A 9 Windshield Wiper Motor B 9 Fog Lamp (Front RH)
A 10 Brake Fluid Level Warning SW B 10 Fog Lamp (Front LH)
A 11 Speed Sensor (Front LH) B 11 Side Marker Lamp (Front RH)
A 12 Airbag Sensor (Front LH) B 12 Side Marker Lamp (Front LH)
A 14 Radiator Fan Resistor B 13 Junction Connector
A 15 Skid Control ECU with Actuator
A 18 Engine Hood Courtesy SW
A 21 Engine Control Module
A 22 Water Level Warning SW
A 23 Security Horn
A 24 Junction Connector
.ir
A 27 Fusible Link Block
46
YARIS (EM01V0U)
G
[H/B]
C25 C4 C20 C11 C5 C12 C13 C6 C14 C7 C30 C23 C3 C26
na
sic
C19
C22
C24
C21
P1
C29
C10
C28
C9
C27
C16
oe
C2 C8 C1 C15 C18 C17
C 1 Starter C17 Throttle Body Assembly

C 2 Crankshaft Position Sensor C18 Camshaft Position Sensor
C 3 VSV (Purge) C19 Engine Coolant Temp. Sensor
C 4 Fuel Injector (No.1) C20 Engine Control Module
C 5 Fuel Injector (No.2) C21 Speed Sensor
C 6 Fuel Injector (No.3) C22 Back–Up Lamp SW
lec
C 7 Fuel Injector (No.4) C23 Air Fuel Ratio Sensor (Bank 1 Sensor 1)
C 8 A/C Compressor C24 Camshaft Timing Oil Control Valve
C 9 Generator C25 Noise Filter
C10 Generator C26 Mass Air Flow Meter
C 11 Ignition Coil (No.1) C27 Park/Neutral Position SW
C12 Ignition Coil (No.2) C28 Electronically Controlled Transmission Solenoid
C13 Ignition Coil (No.3) C29 Speed Sensor (Turbine)
C14 Ignition Coil (No.4) C30 Fusible Link Block
C15 Starter
C16 Engine Oil Pressure SW P 1 Knock Control Sensor (Bank 1)
.ir
47
YARIS (EM01V0U)
[S/D]
A21 A23 A28 A27 A10 A15 A9
na
A7
A11
B14
B15
B4
sic
B13
A22
B6
A5
A25
B9
A24
oe
A6 A3 A18 A8 B2 A12 B5 A14 B10
A 3 A/C Pressure Sensor B 2 Horn

A 5 Windshield Washer Motor B 4 Headlamp (RH)
A 6 Airbag Sensor (Front RH) B 5 Ambient Temp. Sensor
A 7 Speed Sensor (Front RH) B 6 Headlamp (LH)
A 8 Cooling Fan Motor B 9 Fog Lamp (Front RH)
A 9 Windshield Wiper Motor B 10 Fog Lamp (Front LH)
lec
A 10 Brake Fluid Level Warning SW B 13 Junction Connector
A 11 Speed Sensor (Front LH) B 14 Turn Signal, Side Marker and Parking Lamp (RH)
A 12 Airbag Sensor (Front LH) B 15 Turn Signal, Side Marker and Parking Lamp (LH)
A 14 Radiator Fan Resistor
A 15 Skid Control ECU with Actuator
A 18 Engine Hood Courtesy SW
A 21 Engine Control Module
A 22 Water Level Warning SW
A 23 Security Horn
.ir
48
YARIS (EM01V0U)
G
[S/D]
C4 C11 C20 C5 C12 C13 C6 C14 C7 C30
na
C25
P1
C24
C23
C9
C26
sic
C10
C3
C8
C18
C2
C22
C21
oe
C16 C1 C15 C17 C19 C29 C27 C28
C 1 Starter C17 Throttle Body Assembly

C 2 Crankshaft Position Sensor C18 Camshaft Position Sensor
C 3 VSV (Purge) C19 Engine Coolant Temp. Sensor
C 4 Fuel Injector (No.1) C20 Engine Control Module
C 5 Fuel Injector (No.2) C21 Speed Sensor
C 6 Fuel Injector (No.3) C22 Back–Up Lamp SW
lec
C 7 Fuel Injector (No.4) C23 Air Fuel Ratio Sensor (Bank 1 Sensor 1)
C 8 A/C Compressor C24 Camshaft Timing Oil Control Valve
C 9 Generator C25 Noise Filter
C10 Generator C26 Mass Air Flow Meter
C 11 Ignition Coil (No.1) C27 Park/Neutral Position SW
C12 Ignition Coil (No.2) C28 Electronically Controlled Transmission Solenoid
C13 Ignition Coil (No.3) C29 Speed Sensor (Turbine)
C14 Ignition Coil (No.4) C30 Fusible Link Block
C15 Starter
C16 Engine Oil Pressure SW P 1 Knock Control Sensor (Bank 1)
.ir
49
YARIS (EM01V0U)
Position of Parts in Instrument Panel
[H/B]
c1 b1 A19 A26 A17 E10 Q1 Q2
na
V1
W2
sic
W1
E4
E3
E1
oe
A13 A16 A20 E9 E8 E2 J8 J9 E6 E5
A 13 Stop Lamp SW Q 1 Airbag Squib (Front Passenger’s Airbag Assembly)

A 16 Clutch Start SW Q 2 Airbag Squib (Front Passenger’s Airbag Assembly)
A 17 PTC Heater
A 19 Power Steering ECU V 1 Spiral Cable
A 20 Accelerator Position Sensor Steering Pad SW
lec
W 1 Airbag Squib (Steering Wheel Pad)
E 1 Blower SW Spiral Cable
E 2 A/C Thermistor No.1 W 2 Airbag Squib (Steering Wheel Pad)
E 3 Blower Resistor Spiral Cable
E 4 Blower Motor
E 5 A/C SW b 1 Power Steering ECU
E 6 Rear Window Defogger SW Power Steering Motor
E 8 A/C Amplifier
E 9 A/C Amplifier c 1 Power Steering ECU
E 10 Junction Connector Power Steering Torque Sensor
J 8 Airbag Sensor Assembly Center

.ir
50
YARIS (EM01V0U)
G
[H/B]
D24 D31 D25 D23 D7 D36 D37 D2 D27 D39 D1 D38 D35 D34 D32 D26
na
D8
D18
D10
D44
D11
D33
sic
D74
D43
D42
D29
D9
D45
D13
D41
D19
D5
D6
oe
D15 D46 D40 D12 D4 D3 D28 D16 D14 D20 D22 D30 D21 D75
D 1 Combination Meter D26 Theft Warning ECU

D 2 Combination Meter D27 Passenger Seat Belt Warning Lamp
D 3 Spiral Cable D28 Oxygen Sensor (Bank 1 Sensor 2)
D 4 Headlamp Dimmer SW Assembly D29 Light Control Rheostat
D 5 Windshield Wiper SW Assembly D30 Door Lock Control SW
D 6 Windshield Wiper SW Assembly D31 Power Steering ECU
lec
D 7 Hazard Warning Signal SW D32 Antenna Amplifier
D 8 Ignition SW D33 Main Body ECU
D 9 Running Light Relay D34 Junction Connector
D10 Radio Receiver Assembly D35 Junction Connector
D 11 Radio Receiver Assembly D36 Junction Connector
D12 Outer Mirror SW D37 Junction Connector
D13 Key Interlock Solenoid D38 Junction Connector
D14 Cigarette Lighter or Power Outlet D39 Junction Connector
D15 Data Link Connector 3 D40 Junction Connector
D16 Airbag Sensor Assembly Center D41 Junction Connector
D18 Spiral Cable D42 Junction Connector
D19 Unlock Warning SW D43 Fuse Block
D20 A/T Shift Lever Illumination D44 Diode (Starter)
.ir
D21 Parking Brake SW D45 ACC Cut Relay
D22 Shift Lock Control ECU D46 Front Fog Light Relay
D23 Transponder Key ECU D74 Radio Receiver Assembly
D24 Transponder Key Amplifier D75 Stereo Jack Adapter
D25 Security Indicator Lamp
51
YARIS (EM01V0U)
[S/D]
A13 A16 V1 c1 b1 A19 E9 A17 E8 E10 E2 E1 E6 Q1 Q2 E5 E3 E4
na
sic
oe
A29 W1 A20 W2 J8 J9
A 13 Stop Lamp SW Q 1 Airbag Squib (Front Passenger’s Airbag Assembly)

A 16 Clutch Start SW Q 2 Airbag Squib (Front Passenger’s Airbag Assembly)
A 17 PTC Heater
A 19 Power Steering ECU V 1 Cruise Control SW
A 20 Accelerator Position Sensor Spiral Cable
A 29 Cruise Control Clutch SW Steering Pad SW
lec
E 1 Blower SW W 1 Airbag Squib (Steering Wheel Pad)
E 2 A/C Thermistor No.1 Spiral Cable
E 3 Blower Resistor W 2 Airbag Squib (Steering Wheel Pad)
E 4 Blower Motor Spiral Cable
E 5 A/C SW
E 6 Rear Window Defogger SW b 1 Power Steering ECU
E 8 A/C Amplifier Power Steering Motor
E 9 A/C Amplifier
E 10 Junction Connector c 1 Power Steering ECU
Power Steering Torque Sensor
.ir
52
YARIS (EM01V0U)
G
[S/D]
D13 D31 D25 D23 D9 D11 D36 D76 D37 D1 D77 D35 D34 D39 D38 D10 D74 D32
na
D26
D8
D24
D19
D44
sic
D42
D33
D5
D43
D6
D45
D75
D41
D20
D22
D21
oe
D15 D29 D46 D40 D12 D4 D3 D18 D28 D16 D14
D 1 Combination Meter D28 Oxygen Sensor (Bank 1 Sensor 2)

D 3 Spiral Cable D29 Light Control Rheostat
D 4 Headlamp Dimmer SW Assembly D31 Power Steering ECU
D 5 Windshield Wiper SW Assembly D32 Antenna Amplifier
D 6 Windshield Wiper SW Assembly D33 Main Body ECU
D 8 Ignition SW D34 Junction Connector
lec
D 9 Running Light Relay D35 Junction Connector
D10 Radio Receiver Assembly D36 Junction Connector
D 11 Radio Receiver Assembly D37 Junction Connector
D12 Outer Mirror SW D38 Junction Connector
D13 Key Interlock Solenoid D39 Junction Connector
D14 Cigarette Lighter or Power Outlet D40 Junction Connector
D15 Data Link Connector 3 D41 Junction Connector
D16 Airbag Sensor Assembly Center D42 Junction Connector
D18 Spiral Cable D43 Fuse Block
D19 Unlock Warning SW D44 Diode (Starter)
D20 A/T Shift Lever Illumination D45 ACC Cut Relay
D21 Parking Brake SW D46 Front Fog Light Relay
D22 Shift Lock Control ECU D74 Radio Receiver Assembly
.ir
D23 Transponder Key ECU D75 Stereo Jack Adapter
D24 Transponder Key Amplifier D76 Combination Meter
D25 Security Indicator Lamp D77 Hazard Warning Signal SW
D26 Theft Warning ECU
53
YARIS (EM01V0U)
Position of Parts in Body
[5–Door]
U1 F6 F4 K1 F2 F1 K2 U4 U5 F5 X1 M1 H1 H2 H3
na
O1
H4
G2
sic
N1
G1 N4
G4 N3
G5 Z1
G6 N2
L1
oe
Y1 I1 I4 I2 U3 U2 I3 a1 M2
F 1 Power Window SW (Front RH) L 1 License Plate Lamp

F 2 Outer Rear View Mirror (RH)
F 4 Power Window Regulator Motor (Front RH) M 1 Center Stop Lamp
F 5 Door Lock Assembly (Front Passenger’s Side) M 2 Rear Window Defogger
F 6 Speaker (Front Door RH)
N 1 Rear Wiper Motor Assembly
lec
G 1 Power Window Master SW N 2 Back Door Courtesy SW
G 2 Outer Rear View Mirror (LH) N 3 Back Door Lock Assembly
G 4 Power Window Regulator Motor (Front LH) N 4 Back Door Position SW
G 5 Door Lock Assembly (Driver’s Side)
G 6 Speaker (Front Door LH) O 1 Rear Window Defogger
H 1 Power Window SW (Rear RH) U 1 Occupant Classification ECU

H 2 Power Window Regulator Motor (Rear RH) U 2 Occupant Classification Sensor (Front LH)
H 3 Door Lock Assembly (Rear RH) U 3 Occupant Classification Sensor (Rear LH)
H 4 Speaker (Rear RH) U 4 Occupant Classification Sensor (Front RH)
U 5 Occupant Classification Sensor (Rear RH)
I 1 Power Window SW (Rear LH)
I 2 Power Window Regulator Motor (Rear LH) X 1 Side Airbag Squib (RH)
.ir
I 3 Door Lock Assembly (Rear LH)
I 4 Speaker (Rear LH) Y 1 Side Airbag Squib (LH)
K 1 Map Lamp Z 1 Speed Sensor (Rear RH)

K 2 Room Lamp (Center)
a 1 Speed Sensor (Rear LH)
54
YARIS (EM01V0U)
G
[5–Door]
J24 J11 J31 J23 J1 J20 J16 J22
na
J32
J14
sic
J3
J13
J30
oe
J10 J2 J21 J17 J15 J33 J25 J12 J5 J29 J28 J4
J 1 Door Courtesy SW (Front RH) J 20 Pretensioner (RH)

J 2 Door Courtesy SW (Front LH) J 21 Pretensioner (LH)
J 3 Rear Combination Lamp (RH) J 22 Curtain Shield Airbag Squib (RH)
J 4 Rear Combination Lamp (LH) J 23 Curtain Shield Airbag Squib (LH)
J 5 Fuel Suction Pump and Gage Assembly J 24 Occupant Classification ECU
J 10 Front Seat Inner Belt (Driver’s Side) J 25 Canister Pump Module
lec
J 11 Front Seat Inner Belt Assembly (Front RH) J 28 Junction Connector
J 12 Room Lamp (Luggage) J 29 Junction Connector
J 13 Door Control Receiver J 30 Diode (Room Lamp)
J 14 Airbag Sensor (Rear RH) J 31 Noise Filter
J 15 Airbag Sensor (Rear LH) J 32 Door Courtesy SW (Rear RH)
J 16 Side Airbag Sensor (RH) J 33 Door Courtesy SW (Rear LH)
J 17 Side Airbag Sensor (LH)
.ir
55
YARIS (EM01V0U)
[3–Door]
K1 F2 F1 K2 F4 F6 U4 U5 F5 X1 M1 M2
na
U1
G5 O1
G2 N1
G1 N3
sic
G4 N2
G6 Z1
L1
oe
Y1 U2 U3 a1 N4
F 1 Power Window SW (Front RH) N 1 Rear Wiper Motor Assembly

F 2 Outer Rear View Mirror (RH) N 2 Back Door Courtesy SW
F 4 Power Window Regulator Motor (Front RH) N 3 Back Door Lock Assembly
F 5 Door Lock Assembly (Front Passenger’s Side) N 4 Back Door Position SW
O 1 Rear Window Defogger
lec
G 1 Power Window Master SW
G 2 Outer Rear View Mirror (LH) U 1 Occupant Classification ECU
G 4 Power Window Regulator Motor (Front LH) U 2 Occupant Classification Sensor (Front LH)
G 5 Door Lock Assembly (Driver’s Side) U 3 Occupant Classification Sensor (Rear LH)
G 6 Speaker (Front Door LH) U 4 Occupant Classification Sensor (Front RH)
U 5 Occupant Classification Sensor (Rear RH)
K 1 Map Lamp
K 2 Room Lamp (Center) X 1 Side Airbag Squib (RH)
L 1 License Plate Lamp Y 1 Side Airbag Squib (LH)
M 1 Center Stop Lamp Z 1 Speed Sensor (Rear RH)

M 2 Rear Window Defogger
.ir
56
YARIS (EM01V0U)
G
[3–Door]
J24 J11 J23 J31 J20 J16 J26 J14 J22 J3
na
sic
oe
J10 J2 J21 J17 J27 J15 J13 J12 J25 J30 J5 J29 J28 J4 J1
J 1 Door Courtesy SW (Front RH) J 20 Pretensioner (RH)

J 2 Door Courtesy SW (Front LH) J 21 Pretensioner (LH)
J 3 Rear Combination Lamp (RH) J 22 Curtain Shield Airbag Squib (RH)
J 4 Rear Combination Lamp (LH) J 23 Curtain Shield Airbag Squib (LH)
J 5 Fuel Suction Pump and Gage Assembly J 24 Occupant Classification ECU
J 10 Front Seat Inner Belt (Driver’s Side) J 25 Canister Pump Module
lec
J 11 Front Seat Inner Belt Assembly (Front RH) J 26 Speaker (Rear RH)
J 12 Room Lamp (Luggage) J 27 Speaker (Rear LH)
J 13 Door Control Receiver J 28 Junction Connector
J 14 Airbag Sensor (Rear RH) J 29 Junction Connector
J 15 Airbag Sensor (Rear LH) J 30 Diode (Room Lamp)
J 16 Side Airbag Sensor (RH) J 31 Noise Filter
J 17 Side Airbag Sensor (LH)
.ir
57
YARIS (EM01V0U)
[4–Door]
G2 Y1 F6 F4 K1 F2 F1 K2 F7 I3 X1 F5 H1 H2 H3 O1
na
sic
oe
G6 G4 G1 G7 G5 I1 I2 a1 U2 U3 U1 U4 U5 Z1
F 1 Power Window SW (Front RH) K 1 Map Lamp

F 2 Outer Rear View Mirror (RH) K 2 Room Lamp (Center)
F 4 Power Window Regulator Motor (Front RH)
F 5 Door Lock Assembly (Front Passenger’s Side) O 1 Rear Window Defogger
F 7 Door Lock Control SW (Front Passenger’s Side) U 1 Occupant Classification ECU
lec
U 2 Occupant Classification Sensor (Front LH)
G 1 Power Window Master SW U 3 Occupant Classification Sensor (Rear LH)
G 2 Outer Rear View Mirror (LH) U 4 Occupant Classification Sensor (Front RH)
G 4 Power Window Regulator Motor (Front LH) U 5 Occupant Classification Sensor (Rear RH)
G 5 Door Lock Assembly (Driver’s Side)
G 6 Speaker (Front Door LH) X 1 Side Airbag Squib (RH)
G 7 Door Lock Control SW (Driver’s Side)
Y 1 Side Airbag Squib (LH)
H 1 Power Window SW (Rear RH)
H 2 Power Window Regulator Motor (Rear RH) Z 1 Speed Sensor (Rear RH)
H 3 Door Lock Assembly (Rear RH)
I 1 Power Window SW (Rear LH)
.ir
I 2 Power Window Regulator Motor (Rear LH)
I 3 Door Lock Assembly (Rear LH)
58
YARIS (EM01V0U)
G
[4–Door]
na
J23
J22
J44
J38
J1
J12
J13
J32
J45
sic
J34
J11
J41
J24
J43
J2
J36
J10
J42
J21
J17
oe
J33 J15 J20 J29 J28 J5 J25 J16 J35 J39 J30 J40 J14 J37
J 1 Door Courtesy SW (Front RH) J 28 Junction Connector

J 2 Door Courtesy SW (Front LH) J 29 Junction Connector
J 5 Fuel Suction Pump and Gage Assembly J 30 Diode (Room Lamp)
J 10 Front Seat Inner Belt (Driver’s Side) J 32 Door Courtesy SW (Rear RH)
J 11 Front Seat Inner Belt Assembly (Front RH) J 33 Door Courtesy SW (Rear LH)
J 12 Room Lamp (Luggage) J 34 Rear Combination Lamp (RH)
lec
J 13 Door Control Receiver J 35 Rear Combination Lamp (LH)
J 14 Airbag Sensor (Rear RH) J 36 License Plate Lamp (RH)
J 15 Airbag Sensor (Rear LH) J 37 License Plate Lamp (LH)
J 16 Side Airbag Sensor (RH) J 38 Speaker (Rear RH)
J 17 Side Airbag Sensor (LH) J 39 Speaker (Rear LH)
J 20 Pretensioner (RH) J 40 High Mounted Stop Light
J 21 Pretensioner (LH) J 41 High Mounted Stop Light
J 22 Curtain Shield Airbag Squib (RH) J 42 Door Lock Assembly (Luggage)
J 23 Curtain Shield Airbag Squib (LH) J 43 Door Lock Assembly (Luggage)
J 24 Occupant Classification ECU J 44 Rear Window Defogger
J 25 Canister Pump Module J 45 Noise Filter
.ir
59
YARIS (EM01V0U)
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[H/B]
na
sic
Engine Room Main Wire Sensor Wire CA2
Engine Room CA1

No.2 Wire
BA1
oe
A1
Engine Wire
A2
lec
C1 C2 B1
CP1
.ir
60
YARIS (EM01V0U)
G
[S/D]
na
sic
Engine Room Main Wire Sensor Wire CA2
CA1
Engine Room
No.2 Wire
BA1
oe
A1
Engine Wire
A2
B1
lec
C1 C2
CP1
.ir
61
YARIS (EM01V0U)
[H/B]
AD1 AD5 AA2 AA1 DE1 Instrument Panel DQ1 Instrument Panel Wire
Wire Assembly
na
Roof Wire
Instrument Panel
AE1 No.2 Wire
ED1 Front Door RH

Wire
sic
AJ1
JD2 FD2
AD4
FD1
JD1
Floor Wire
Front Door LH
oe
Wire GD1 GD2 AD3 AD2 Engine Room Main Wire

D3
lec
A3
D2
.ir
D1
62
YARIS (EM01V0U)
G
[S/D]
AE1 AD5 ED1 AA1 DE1 Instrument Panel DQ1 Instrument Panel Wire
Wire Assembly
na
Roof Wire
Instrument Panel
AD1 No.2 Wire
AD4 Front Door RH

Wire
sic
JD3
AJ1 FD2
JD2
FD1
JD1
Floor Wire
Front Door LH
oe
Wire GD2 GD1 AD3 AD2 AA2 Engine Room Main Wire

D3
lec
A3
D2
.ir
D1
63
YARIS (EM01V0U)
[5–Door]
na
sic
IJ1 Front Door JX1 MJ1 HJ1 Seat Airbag Rear Door
RH Wire RH Wire No.1 Wire
J1
Rear Window
No.1 Wire
O1
Roof Wire
Front Door ZJ1

LH Wire
Back Door
oe
No.2 Wire
JY1 N1
Seat Airbag MN1

LH Wire
Skid Control
Sensor RH Wire
Back Door
No.1 Wire
lec
Rear Door No.2 Front Seat Skid Control J2 Luggage Room
Floor Wire Wire RH Wire aJ1 Sensor LH Wire LJ1 No.2 Wire
.ir
64
YARIS (EM01V0U)
G
[3–Door]
na
sic
Seat Airbag Front Door JX1 MJ1 Seat Airbag J1
LH Wire RH Wire RH Wire
Rear Window
No.1 Wire
O1
Roof Wire
ZJ1
Front Door
LH Wire Back Door
oe
No.2 Wire
N1
MN1
Skid Control
Sensor RH Wire
Back Door
No.1 Wire
lec
Front Seat Skid Control J2 Luggage Room
JY1 Floor Wire RH Wire aJ1 LJ1 No.2 Wire
Sensor LH Wire
.ir
65
YARIS (EM01V0U)
[4–Door]
na
sic
Front Door JX1 Seat Airbag HJ1 Rear Door No.1
RH Wire RH Wire Wire
Rear
Window
Roof Wire No.1 Wire
Front Door O1
LH Wire
ZJ1
Floor Wire
oe
J1
Skid Control
Sensor RH Wire
lec
Seat Airbag Rear Door Skid Control Front Seat J2
IJ1 LH Wire JY1 No.2 Wire aJ1 Sensor LH Wire RH Wire
.ir
66
YARIS (EM01V0U)
SYSTEM CIRCUITS H
2007 YARIS
ELECTRICAL WIRING DIAGRAM
SYSTEM CIRCUITS
na
Page
ABS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 154
Air Conditioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
Audio System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 222
Back–Up Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
Cigarette Lighter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220
Combination Meter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 226
sic
Cooling Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Cruise Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102
Data Link Connector 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Door Lock Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 184
Electronically Controlled Transmission and A/T Indicator . . . . . . . . . . . . . . 96
Engine Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Engine Immobiliser System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
EPS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 174
Front Fog Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Front Wiper and Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208
Headlight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144
oe
Ignition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
Illumination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 134
Interior Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
Key Reminder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 150
Light Reminder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 150
Multiplex Communication System (CAN) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Power Outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220
Power Source . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
Power Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 178
Rear Window Defogger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 216
lec
Rear Wiper and Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Remote Control Mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 218
Seat Belt Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 168
Shift Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
SRS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 159
Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Stop Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
Taillight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 134
Theft Deterrent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 200
Turn Signal and Hazard Warning Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Wireless Door Lock Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192
.ir
67
YARIS (EM01V0U)
Power Source
40A HTR SUB2 30A ABS2/VSC2

1
na
B 1 2 1 2
1E
50A EPS 30A HTR SUB1
1 2 1 2
50A ABS1/VSC1 30A RDI
1 2 1 2
W
40A HTR
1 2
sic
C10
W
Generator 7. 5A ALT–S
1
1 2
1D
B
1 15A DOME
oe
1 2
1
W
B
30A ST
1 2
1 C 1 A 1 B 2 B
7. 5A ECU–B
L
1 2
A27(B), A28(A), C30(C)
60A MAIN
120A ALT
Fusible Link Block
10A ETCS
1 2
lec
10A HAZ
1 2
10A H–LP LH/H–LP LO LH
Battery 1 2 L
10A H–LP RH/H–LP LO RH
1 2
.ir
68
YARIS (EM01V0U)
B B
EFI Relay
20A EFI 10A EFI2

na
4 4
1 2 B B 1 2
1A AA1 1
10A HORN
1 2
15A AM2
1
W 1 2
1C
Y
sic
ACC 2 W
Y 4 AM1 IG1 1 G
IG2 Relay
GR 5 AM2 IG2 6 P
3 1B 2 1B 4 1B 1 1B
ST2 7 B
oe
D8
Ignition SW
GR
W
P
14 AA2
P
5 AD4 3 AD2 4 AD2

lec
W–B
GR
W
P
L L
.ir
A1
69
YARIS (EM01V0U)
Power Source
B B
na
Y Y
sic
W
G G
1 7. 5A ACC2 2 B
oe
D43
W
W
P
Fuse Block
8 4S 2 3
ACC Cut Relay
15A CIG
D45
13 4B 1 4
5 7. 5A ACC
L
4F
G
L
lec
7. 5A IGN
18 AD4
4 7. 5A MET
W W
4F
G
L 13
ACCR
A21
Engine Control
Module
.ir
70
YARIS (EM01V0U)
T–LP Relay
1 10A TAIL
B
4G ∗ 1 : H/B, S/D ∗3
(∗1) (∗1) (∗1) (∗1) ∗ 2 : Except ∗1
7. 5A PANEL1 ∗ 3 : Cold Area Spec. ,
w/ Engine Immobiliser System,
(∗1) (∗1) (∗1) (∗1) w/ ABS,
na
w/ Rear Window Defogger,
30A DEF w/ Door Lock Control,
DEF Relay
1 2 10A ID/UP/MIR HTR w/ Daytime Running Light,
w/ Air Conditioning
15A FR FOG
7. 5A OBD2
25A D/L
1
Y
4F
sic
10A STOP
25A AM1
3
G
4F
10A TAIL 4
W
4M
(∗2) (∗2) (∗2)
13
30A POWER B1
Headlamp Dimmer SW Assembly

PWR Relay
1 2
B1 T1
OFF
oe
Light
Control
20A RL DOOR SW Tail
Head
20A RR DOOR
D4
T1
10
IG 1 Relay
5 3 10A ECU–IG G
(∗2)
2 1 25A WIP
15A WSH 10 7. 5A PANEL2 7. 5A PANEL1

lec
4E
17 4E 7 4M (∗2) (∗2) (∗2)
10A GAUGE
15A RR WIP
W–B
W–B
7. 5A A/C
.ir
1 6A
D1 D2
71
YARIS (EM01V0U)
Power Source
: Parts Location
46 (H/B) 47 (H/B) 51 (H/B)
A21 C10 D8
48 (S/D) 49 (S/D) 53 (S/D)
na
43, 46 (H/B) 42, 47 (H/B) 45, 51 (H/B)
A27 B C30 C D43
43, 48 (S/D) 42, 49 (S/D) 45, 53 (S/D)
43, 46 (H/B) 51 (H/B) 51 (H/B)
A28 A D4 D45
43, 48 (S/D) 53 (S/D) 53 (S/D)
: Relay Blocks

1 24 Engine Room R/B (Engine Compartment Left)
: Junction Block and Wire Harness Connector
sic
1A
1B 25
1C Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
1D
24
1E
4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel)
4E
30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4F
4G 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel)
4M
4S
oe
6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel)
: Connector Joining Wire Harness and Wire Harness

62 (H/B)
AA1
63 (S/D)
Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left)
62 (H/B)
AA2
63 (S/D)
62 (H/B)
AD2
63 (S/D)
Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
62 (H/B)
AD4
lec
63 (S/D)
: Ground Points

60 (H/B)
A1 Left Suspension Tower
61 (S/D)
62 (H/B)
D1 Left Kick Panel
63 (S/D)
62 (H/B)
D2 Right Kick Panel
63 (S/D)
.ir
72
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
73
YARIS (EM01V0U)
Starting
(BAT)
30A
ST
na
2
5 2
ST
sic
Relay
3 1
1 1 1
V
B
15
A25
Junction Connector
13 14 12
oe
(∗2)
(∗1)
BR
W
B
10 CA1 9 CA1
BR
(∗1)
W
V
1
Clutch Start SW
1 B
1
A 5
A16
lec
B L C27
2 Park/Neutral
M P Position SW
W–B
(∗2)
B
N
C1(A), C15(B)
Starter 4
(∗1)
GR
10 CA2
Battery
GR 2 1 Y
(∗1)
Y 3 A25
Junction
(∗2) Connector
.ir
A1
74
YARIS (EM01V0U)
(BAT) ∗ 1 : A/T
∗ 2 : M/T
15A
AM2
na
5 AM2 IG2 B
2
ST2 7 B
1 1B
D8
GR
Ignition SW
4 AD2 9 AD4
Engine Control Module
B
14 A 1
A21(A), C20(B)
STSW D44
Diode (Starter)
sic
GR STA STAR
2
48 A 52 B
O
8 CA1
BR
SB
O
oe
12 AA2
O
5 AA2 1 AD4
BR
O
7 5
D36
Junction Connector
6
GR
lec
10 AD4
Y
13 AA2
Y
.ir
75
YARIS (EM01V0U)
Starting
: Parts Location
50 (H/B) C1 A 49 (S/D) 51 (H/B)
A16 D8
52 (S/D) 47 (H/B) 53 (S/D)
C15 B
na
46 (H/B) 49 (S/D) 51 (H/B)
A21 A D36
48 (S/D) 47 (H/B) 53 (S/D)
C20 B
46 (H/B) 49 (S/D) 51 (H/B)
A25 D44
48 (S/D) 47 (H/B) 53 (S/D)
C27
C1 A 47 (H/B) 49 (S/D)
: Relay Blocks


sic
1B 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)

62 (H/B)
AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left)
63 (S/D)
62 (H/B)
AD2
63 (S/D)
62 (H/B)
AD4
63 (S/D)
oe
60 (H/B)
CA1
61 (S/D)
Engine Wire and Engine Room Main Wire (Engine Compartment Left)
60 (H/B)
CA2
61 (S/D)
: Ground Points

60 (H/B)
61 (S/D)
lec
.ir
76
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
77
YARIS (EM01V0U)
Charging
(BAT) (IG) (IG)
7. 5A ALT–S
10A GAUGE
7. 5A MET
∗ 1 : w/ Daytime Running Light
∗ 2 : w/o Daytime Running Light
na
2
1 1 4M 19 4B
Running Light Relay

W
G
B
A/C Amplifier
1 A
C20
ALT ALT CHG–
D9
E9
D1(A), D2(B), D76(C)

Combination Meter
24 50 9
Charge
sic
(∗1)
G
P
1 B (H/B)
1 C (S/D)
13
Connector
7 AE1
Junction
14 SB
D39
(∗1)
12
(∗1)
(∗2)
P
L
15 CA1 5 CA1 15 AD3 1 CA1
oe
W
G
P
L
7 AA2
B
4 CA1
P
1
L
lec
Fusible Link Block
C9(A), C10(B)
120A ALT
1 B 3 A 1 A Generator 4 A 2 A
B M S L IG
C30
Battery
IC Regulator
.ir
78
YARIS (EM01V0U)
: Parts Location
47 (H/B) 42, 47 (H/B) D9 53 (S/D)
C9 A C30
49 (S/D) 42, 49 (S/D) 51 (H/B)
D39
na
47 (H/B) 51 (H/B) 53 (S/D)
C10 B D1 A
49 (S/D) 53 (S/D) D76 C 53 (S/D)
47 (H/B) D2 B 51 (H/B) 50 (H/B)
C20 E9
49 (S/D) D9 51 (H/B) 52 (S/D)
: Relay Blocks

sic
4M 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)

62 (H/B)
63 (S/D)
62 (H/B)
AD3 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
63 (S/D)
62 (H/B)
AE1 Engine Room Main Wire and Instrument Panel No.2 Wire (Instrument Panel Left)
63 (S/D)
oe
60 (H/B)
CA1 Engine Wire and Engine Room Main Wire (Engine Compartment Left)
61 (S/D)
lec
.ir
79
YARIS (EM01V0U)
Ignition
(BAT)
GR
D8 15A
AM2
Ignition SW
na
2
5 AM2 IG2 6 P
ST2
5 AD4 4 AD2 R
R
P
sic
14 AA2 11 CA1
GR
R
P
2 1B 1 1B 4 1B
Noise Filter
IG2
oe
C25
Relay
3 1B
W–B
lec
.ir
A1
80
YARIS (EM01V0U)
na
R
sic
R R
LG
BR
LG
R
R
C11 C12 C13 C14
Ignition Coil Ignition Coil Ignition Coil Ignition Coil
1 (No. 1) 1 (No. 2) 1 (No. 3) 1 (No. 4)
+B +B +B +B
oe
GND IGT IGF IGF IGT2 GND IGF GND IGT3 IGF GND IGT4
4 3 2 2 3 4 2 4 3 2 4 3
W–B
W–B
W–B
W–B
LG
W
G
Y
L
lec
Y Y
W–B W–B
W–B
85 81 84 83 82
IGT1 IGF1 IGT2 IGT3 IGT4
C20
.ir
C1
81
YARIS (EM01V0U)
Ignition
: Parts Location
47 (H/B) C13 49 (S/D) 47 (H/B)
C11 C25
49 (S/D) 47 (H/B) 49 (S/D)
C14
na
47 (H/B) 49 (S/D) 51 (H/B)
C12 D8
49 (S/D) 47 (H/B) 53 (S/D)
C20
C13 47 (H/B) 49 (S/D)

62 (H/B)
sic
63 (S/D)
62 (H/B)
AD2
63 (S/D)
62 (H/B)
AD4
63 (S/D)
60 (H/B)
61 (S/D)
: Ground Points

60 (H/B)
oe
61 (S/D)
60 (H/B)
C1 Engine Block Left
61 (S/D)
lec
.ir
82
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
83
YARIS (EM01V0U)
Engine Control
(BAT) (BAT)
20A 15A
EFI AM2
na
2 2
EFI IG2 5 AM2 IG2 6

Relay Relay
ST2
D8
1 1A 4 1A 3 1A 2 1A 3 1B 2 1B 4 1B 1 1B Ignition SW
sic W–B
W–B
GR
GR
GR
R
Y
P
14 AA2 4 AD2 5 AD4
11 CA1
P
P
R
oe
BR
LG
R
Fuel Injector (No. 1)

1 1 1 1
C4
C5
C6
C7
2 2 2 2
L
GR
SB
P
lec
GR
SB
GR
Y
W–B
W–B
.ir
A1
84
YARIS (EM01V0U)
(IG) (BAT)
7. 5A 10A
IGN STOP
na
18 4B
C/OPN
Relay
B
27 4B 9 4B 5 4E 11 4B 8 4A
3 2
A13
Stop Lamp SW
P
sic R
4 1
G
Y
A21(A), C20(B)
Engine Control Module 35 A 36 A
ST1– STP
Fuel Suction Pump and
4
Gage Assembly
FC IGSW # 40 # 30 # 20 # 10 MREL BATT

Pump
7 A 28 A 105 B 106 B 107 B 108 B 44 A 20 A

M
J5
oe
5
GR
GR
SB
R
V
Y
L
12 AD4
W–B
P
lec
GR
SB
GR
B B B B
Y
W–B
.ir
J1
85
YARIS (EM01V0U)
Engine Control
(BAT) (BAT)
15A 10A
DOME ETCS
na
2
1 1
Engine Coolant Temp. Sensor

P
Park/Neutral Position SW (A/T)
2 3
ACC Cut Relay

L
1
Clutch Start SW (M/T)
GR
13 4B
D45
P
1 4
C19
Ignition SW
L
8 4S 2 24 AA2
sic
18 AD4
BR
O
B
GR
G
L
A21(A), C20(B)
14 A 52 B 48 A Engine Control Module 13 A 96 B 97 B 3 A
STSW STAR STA ACCR ETHW THW +BM
+B2 VPMP VCPP PPMP EPPM MPMP

1 A 42 A 70 B 71 B 94 B 34 A
O
V
L
oe
B
15 CA2 16 CA2 17 CA2 14 CA2
BR
O
B
V
L
6 AA1 10 AA1 9 AA1 3 AA1 5 AA1

10A
EFI2
BR
BR
O
B
1
4 AJ1 1 AJ1 7 AJ1 6 AJ1 5 AJ1 2 AJ1 3 AJ1
1
BR
O
V
V
L
lec
B
9 8 4 3 2 1 6
VLVB VGND VCC VOUT SGND MTRB MGND
Canister Pump Module
4
B B
AA1
M
Canister Pressure Sensor
B
J25
Vent Valve Leak Detection Pump
B
.ir
C2
86
YARIS (EM01V0U)
∗ 1 : H/B, S/D ∗3
(BAT) ∗ 2 : Except ∗1
4 4M
∗ 3 : Cold Area Spec. ,
(∗1)
(∗1)
(∗2)
120A ALT
w/ ABS,
Link Block

na
10A
Fusible
T–LP
(∗2)
TAIL w/ Daytime Running Light,
W
A28
Relay
1 w/ Air Conditioning
(∗1)
(∗1)
B
13
B1

10A B1 T1
TAIL
Light OFF
Control
SW Tail
Head
1 4G 15 4B 10 4E
sic
D4
T1
(∗2)
G
10
G
A21(A), C20(B)
Engine Control Module 31 A
ELS
+B IMI IMO EOM PRG THA E2G VG ETHA

2 A 11 A 10 A 9 A 49 B 65 B 116 B 118 B 88 B
W
oe O
BR
8 AD4 17 AD4 7 AD4

GR
LG
O
P
1
VSV (Purge)
BR
W
O
B
C3
2
13 12 11 4 2 3 5
EFIO EFII EGND THA E2G VG E2
lec
+B
D23 1 C26
Transponder Key ECU Mass Air Flow Meter
V
1 12
B V V V B B
AA2 CA1
9 5
.ir
B B B B
AA2 AD5
87
YARIS (EM01V0U)
Engine Control
na
FAN NO. 1 Relay
FAN NO. 2 Relay

Ignition Coils
sic
LG
LG
W
O
Y
85 B 84 B 83 B 82 B 81 B 21 A 22 A
IGT1 IGT2 IGT3 IGT4 IGF1 FAN FAN2
HA1A A1A– A1A+ HT1B EX1B

109 B 113 B 112 B A21(A), C20(B) 47 B 87 B
oe
GR
LG
(Shielded)
LG
G
5 CA2 4 CA2
GR
LG
1 4 3
HA1A A1A– A1A+
4 AD5 3 AD5
Oxygen Sensor (Bank 1 Sensor 2)
lec
+B
2 C23
Air Fuel Ratio Sensor
GR
LG
(Bank 1 Sensor 1)
1 4
HT1B E2
B
D28
+B OX1B
2 3
W
B
W
B
(Shielded)
.ir
B
88
YARIS (EM01V0U)
(BAT)
30A
DEF
na
2
11 4M
A20
Accelerator Position Sensor
DEF
Relay
10A
ID/UP/
MIR HTR
VCP2 VPA2 EPA2 VCPA VPA EPA
1 3 2 4 6 5
V
sic
8 AD3
BR
W
G
R
B
L
V
A21(A), C20(B)
Engine Control Module 33 A 58 A 56 A 60 A 57 A 55 A 59 A
ELS3 VCP2 VPA2 EPA2 VCPA VPA EPA
OX1B KNK1 EKNK NE+ NE– G2+

64 B 110 B 111 B 122 B 121 B 99 B
(Shielded)
(Shielded)
P
oe
G
G
R
2 CA2 3 CA2 1 CP1 2 CP1

(Shielded)
(Shielded)
W
P
B
L
W
B
(Shielded)
Knock Control Sensor
2
Crankshaft Position
Camshaft Position
1 2
lec (Bank 1)
Sensor
Sensor
1 AD5 2 AD5
C18
C2
P1
2 1
1
(Shielded)
(Shielded)
.ir
BR
C1
89
YARIS (EM01V0U)
Engine Control
na
C17
Throttle Body Assembly
E2 VC VTA VTA2 M+ M–
3 5 6 4 2 1
sic
(Shielded)
GR
W
R
V
BR
A21(A), C20(B)
91 B 67 B 115 B 114 B 42 B 41 B 63 B Engine Control Module
ETA VCTA VTA1 VTA2 M+ M– GE01
OC1+ OC1– EC E02 E1 ME01 E01 E04 E03 ALT

100 B 123 B 32 A 44 B 104 B 43 B 45 B 46 B 86 B 50 B
oe
W–B
W–B
P
W–B
W–B
BR
BR
BR
Camshaft Timing Oil Control Valve
W
R
1
lec
3
M
C24
C9
Generator
.ir
A1 C1 C2
90
YARIS (EM01V0U)
na
sic
A21(A), C20(B)
TC TACH SPD CANL CANH W

27 A 15 A 8 A 49 A 41 A 24 A
D16
oe
Airbag Sensor Assembly
Center
LG
W
P
B
L
23 4B 26 4B 16 AD4 CANL CANH 15 AD4 17 AD3

22 13
13 AD4
W
B
L
12 4D 8 4C
15 19 8 4
D41
Junction
Connector
SB
LG
P
22 11
lec W
13 9
TC TAC
22 11
D42
Junction
Connector
D15 B
18 7
Data Link Connector 3
W
.ir
SB
91
YARIS (EM01V0U)
Engine Control
(IG) (BAT) (IG)
7. 5A 7. 5A 10A
MET ECU–B ECU–IG
na
2
1 4M 1 30 4B 24 4B
B
L
L
2 4S
25 AA2
B
16
A25
L
Junction
Connector
sic
20
D1(A), D2(B), D76(C)
1 A Combination Meter 2 A
B
11 CA2
B
5V IC
1
Speed Sensor
Speedometer
Tachometer
IG+
oe
C21
SI SE
Indicator Lamp
Malfunction
3 2
CPU
W–B
CAN Controller
P
12 CA2 13 CA2
CAN I/F I/F I/F

W–B
P
lec
6 AA2 23 AA2
4 B (H/B) 20 A 21 A 24 A 16 A 17 A
4 C (S/D)
W–B
BR
SB
W
G
B
11 AD3
W
.ir
SB
D3 A1
92
YARIS (EM01V0U)
System Outline
1. Electronic Fuel Injection
It controls to have appropriate fuel injection according to the basic injection time. The basic injection time is calculated to fit
the engine condition and is corrected with signals from various sensors.
2. Electronic Spark Advance
na
Appropriate ignition is conducted according to the basic ignition timing which is calculated to fit the engine condition after
correcting it with signals from various sensors.
3. Electronic Throttle Control System–intelligent
It controls to have appropriate throttle opening according to the throttle opening calculated to fit the engine condition after
correcting it with signals from various sensors.
4. Variable Valve Timing–intelligent
It improves engine output, reduces exhaust gas and improves fuel consumption by varying the phase of the intake camshaft
in accordance with the engine condition.
5. Electric Fan Control
It controls the switching ON/OFF and fan speed of the cooling fan according to the coolant temperature and air conditioner’s
sic
condition.
6. Fuel Pump Control
It turns ON/OFF the fuel pump according to the starter signal and engine speed signal. It stops the fuel pump operation
according to signals from the airbag sensor assembly center.
7. Air Conditioning Cut–Off Control
It reduces load of the air conditioner’s compressor in acceleration in order to secure the drivability.
8. Canister Purge Control
It controls the purge flow volume of the canister according to the coolant temperature and driving condition.
9. Cranking Hold Control
It continues to supply electricity to the starter between the start of cranking and the engine start in order to prevent the
engine start failure by the key’s switching off just before the engine’s complete explosion.
oe
10. Oxygen Sensor Control
It switches ON/OFF the oxygen sensor according to the coolant temperature and driving condition.
11. Diagnosis
It realizes accurate and detailed diagnosis of a failure such as calling the SAE specified diagnosis code data and active test
by using the diagnosis tool.
12. Fail–Safe
When the engine control module detects abnormality in signals of the sensors, it stops or continues to control the engine by
using the standard values in the engine control module.
lec
.ir
93
YARIS (EM01V0U)
Engine Control
: Parts Location
50 (H/B) 47 (H/B) D15 53 (S/D)
A13 C17
52 (S/D) 49 (S/D) 51 (H/B)
D16
na
50 (H/B) 47 (H/B) 53 (S/D)
A20 C18
52 (S/D) 49 (S/D) 51 (H/B)
D23
46 (H/B) 47 (H/B) 53 (S/D)
A21 A C19
48 (S/D) 49 (S/D) 51 (H/B)
D28
46 (H/B) 47 (H/B) 53 (S/D)
A25 C20 B
48 (S/D) 49 (S/D) 51 (H/B)
D41
43, 46 (H/B) 47 (H/B) 53 (S/D)
A28 C21
43, 48 (S/D) 49 (S/D) 51 (H/B)
D42
47 (H/B) 47 (H/B) 53 (S/D)
C2 C23
49 (S/D) 49 (S/D) 51 (H/B)
D45
47 (H/B) 47 (H/B) 53 (S/D)
C3 C24
sic
49 (S/D) 49 (S/D) D76 C 53 (S/D)
47 (H/B) 47 (H/B) 55 (5–Door)
C4 C26
49 (S/D) 49 (S/D) J5 57 (3–Door)
47 (H/B) 51 (H/B) 59 (4–Door)
C5 D1 A
49 (S/D) 53 (S/D) 55 (5–Door)
47 (H/B) D2 B 51 (H/B) J25 57 (3–Door)
C6
49 (S/D) 51 (H/B) 59 (4–Door)
D4
47 (H/B) 53 (S/D) 47 (H/B)
C7 P1
49 (S/D) 51 (H/B) 49 (S/D)
D8
47 (H/B) 53 (S/D)
C9
49 (S/D) D15 51 (H/B)
oe
: Relay Blocks

1A
25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
1B
4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel)
lec
4C
4D 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4E
4M
4S
.ir
94
YARIS (EM01V0U)
62 (H/B)
AA1
63 (S/D)
na
62 (H/B)
AA2
63 (S/D)
62 (H/B)
AD2
63 (S/D)
62 (H/B)
AD3
63 (S/D)
62 (H/B)
AD4
63 (S/D)
62 (H/B)
AD5
63 (S/D)
62 (H/B)
AJ1 Engine Room Main Wire and Floor Wire (Instrument Panel Left)
sic
63 (S/D)
60 (H/B)
CA1
61 (S/D)
60 (H/B)
CA2
61 (S/D)
60 (H/B)
CP1 Engine Wire and Sensor Wire (Engine Compartment Center)
61 (S/D)
: Ground Points

60 (H/B)
61 (S/D)
oe
60 (H/B)
C1
61 (S/D)
Engine Block Left
60 (H/B)
C2
61 (S/D)
62 (H/B)
D3 Instrument Panel Reinforcement Left
63 (S/D)
64 (5–Door)
Right Rear Quarter Panel
J1 65 (3–Door)
66 (4–Door) Lower Back Panel Right
lec
.ir
95
YARIS (EM01V0U)
ECT and A/T Indicator
(BAT) (IG) (BAT)
20A 7. 5A 10A
EFI IGN STOP
na
2
9 4B 27 4B 18 4B
Park/Neutral Position SW
EFI
Relay
B
R
1 1A 4 1A 3 1A 2 1A 3 2
A13
Stop Lamp SW
sic W–B
GR
Y
4 1
BR
G
O
Y
A21(A), C20(B)
35 A 36 A Engine Control Module 52 B 48 A
ST1– STP STAR STA
IGSW MREL +B2 +B BATT

28 A 44 A 1 A 2 A 20 A
oe
GR
R
Y
lec
W–B
.ir
A1
96
YARIS (EM01V0U)
na
A20
P
Speed Sensor (Turbine)

1
1

1 3 2 4 6 5
C19
C29
2 2
sic
BR
W
G
R
B
L
G
P
B
L
96 B 97 B 125 B 124 B 58 A 56 A 60 A 57 A 55 A 59 A
ETHW THW NT+ NT– VCP2 VPA2 EPA2 VCPA VPA EPA
A21(A), C20(B)
NE+ NE– EC E02 E1 ME01 E01 E04 E03
122 B 121 B 32 A 44 B 104 B 43 B 45 B 46 B 86 B
oe
W–B
W–B
(Shielded)
P
L
W–B
W–B
BR
BR
W
B
Crankshaft Position
1
lec
Sensor
C2
2
.ir
BR
C1 A1 C1 C2
97
YARIS (EM01V0U)
na
sic
A21(A), C20(B)
TC TACH SPD CANL CANH

27 A 15 A 8 A 49 A 41 A
oe LG
W
P
L
23 4B 26 4B 16 AD4 15 AD4
13 AD4
W
12 4D 8 4C
15 4
D41
Junction
Connector
SB
LG
P
22 11
lec W
13 9
TC TAC
22 11
D42
Junction
Connector
D15 18 7
W
.ir
SB
98
YARIS (EM01V0U)
(BAT) (IG)
10A 10A
ETCS GAUGE
na
G
2
1 19 4B
2 1 CA1
RB
GR
G
C27
PL RL NL DL 2L LL
6 1 9 7 3 8
24 AA2 L
sic GR
SB
G
R
L
14 CA1
A21(A), C20(B)
Engine Control Module 3 A 73 B 53 B 54 B 55 B 74 B 56 B
+BM P R N 2 L D
L
S1 S2 SLU+ SLU– SLT+ SLT– ST THO1 ETHO ODMS
79 B 78 B 57 B 77 B 76 B 75 B 80 B 72 B 95 B 26 A
22 AA2
oe
GR
SB
W
O
O
P
B
L
L
14 AD3 2 AD3
5 10 4 9 3 8 2 1 6
S1 S2 SLU+(H/B) SLU– SLT+ SLT– ST THO E2
SL(S/D)
O
L
GR
BR
LG
W
O
B
Shift Lock Control ECU

9
NSSD
Transmission
lec
Control SW
D22
AT3
3
C28
Electronically
Controlled Transmission
Solenoid
G G
W W
.ir
SB SB
99
YARIS (EM01V0U)
(BAT) (IG) (IG)
7. 5A 7. 5A 10A
ECU–B MET ECU–IG
na
2
1 1 4M 24 4B
B
L
16
A25
25 AA2 Junction
Connector
20
B
L
sic
B
30 4B
11 CA2
2 4S
L
D1
B
2 1 Combination Meter
(S/D)
(S/D)
(S/D)
(S/D)
(S/D)
(S/D) 1
Speed Sensor
IG+
oe
C21
SI SE
R
D
P
5V IC
3 2
(S/D)
(S/D)
(S/D)
(S/D)
(S/D)
(S/D)
W–B
LED Driver
P
12 CA2 13 CA2
CPU
CAN Controller
W–B
P
Speedometer
Tachometer
lec
6 AA2 23 AA2
CAN I/F
W–B
P
I/F I/F
20 21 24 16 17 11 AD3
BR
SB
W
G
W
.ir
SB
D3 A1
100
YARIS (EM01V0U)
: Parts Location
50 (H/B) C19 49 (S/D) 51 (H/B)
A13 D1
52 (S/D) 47 (H/B) 53 (S/D)
C20 B
na
50 (H/B) 49 (S/D) 51 (H/B)
A20 D15
52 (S/D) 47 (H/B) 53 (S/D)
C21
46 (H/B) 49 (S/D) 51 (H/B)
A21 A D22
48 (S/D) 47 (H/B) 53 (S/D)
C27
46 (H/B) 49 (S/D) 51 (H/B)
A25 D41
48 (S/D) 47 (H/B) 53 (S/D)
C28
47 (H/B) 49 (S/D) 51 (H/B)
C2 D42
49 (S/D) 47 (H/B) 53 (S/D)
C29
C19 47 (H/B) 49 (S/D)
: Relay Blocks
sic
1A 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
4C
30
4D
Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4M
31
4S
oe
62 (H/B)
63 (S/D)
62 (H/B)
AD3
63 (S/D)
62 (H/B)
AD4
63 (S/D)
60 (H/B)
CA1
61 (S/D)
lec
60 (H/B)
CA2
61 (S/D)
: Ground Points

60 (H/B)
61 (S/D)
60 (H/B)
C1
61 (S/D)
Engine Block Left
60 (H/B)
C2
61 (S/D)
62 (H/B)
.ir
63 (S/D)
101
YARIS (EM01V0U)
Cruise Control
(BAT) (IG) (BAT)
20A 7. 5A 10A
EFI IGN STOP
na
2
9 4B 27 4B 18 4B
EFI
Relay
B
R
1 1A 4 1A 3 1A 2 1A 3 2
A13
Stop Lamp SW
sic W–B
GR
Y
4 1
G
Y
A21(A), C20(B)
35 A 36 A Engine Control Module
ST1– STP
IGSW MREL +B2 +B BATT

28 A 44 A 1 A 2 A 20 A
oe
GR
R
Y
lec
W–B
.ir
A1
102
YARIS (EM01V0U)
na
A20

1 3 2 4 6 5
sic
BR
W
G
R
B
L
58 A 56 A 60 A 57 A 55 A 59 A
A21(A), C20(B)
TC TACH EC E02 E1 ME01 E01 E04 E03
27 A 15 A 32 A 44 B 104 B 43 B 45 B 46 B 86 B
oe
W–B
W–B
LG
P
23 4B
13 AD4
W–B
W–B
BR
BR
W
B
12 4D
LG
P
lec
13 9
TC TAC
D15
.ir
A1 C1 C2
103
YARIS (EM01V0U)
Cruise Control
(BAT)
10A
ETCS
na
2
1
C17
GR
3 5 6 4 2 1
24 AA2
sic
(Shielded)
GR
W
R
V
Y
GR
BR
A21(A), C20(B)
3 A 91 B 67 B 115 B 114 B 42 B 41 B 63 B Engine Control Module
+BM ETA VCTA VTA1 VTA2 M+ M– GE01
CCS SPD CANL CANH

40 A 8 A 49 A 41 A
oe
W
V
L
L
6 AD4 26 4B 16 AD4 15 AD4
W
L
L
8 4C
15 4
D41
Junction
2 A 1 A Connector
BR
SB
D3(A), V1(B)
ECC CCS Spiral 22 11
Cable
lec
4 B 3 B
W
7
D34
Junction MAIN
Connector 22 11
D42
6 Junction
Connector
+RES 18 7
BR
6 AD2 –SET
G
BR
CANCEL
W
13 CA1
.ir
V1(B)
Cruise Control SW SB
BR
C1
104
YARIS (EM01V0U)
(IG) (IG)
10A 10A
ECU–IG GAUGE
na
24 4B 19 4B
B 21 16 B G
(M/T) (M/T) (A/T)
A25
Junction
1 Connector 2 1 CA1
Cruise Control
D
Clutch SW
7
G
A29
2 (A/T)
sic
C27
L
14 (A/T)
L L
CA1
(M/T)
A21(A), C20(B)
Engine Control Module 56 B
D
S1 S2 SLU+ SLU– SLT+ SLT– ST THO1 ETHO

79 B 78 B 57 B 77 B 76 B 75 B 80 B 72 B 95 B
oe
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
GR
SB
W
O
G
P
B
L
5 10 4 9 3 8 2 1 6
S1 S2 SL SLU– SLT+ SLT– ST THO E2
GR
BR
LG
W
O
B
Y
lec
C28
Electronically
Solenoid
G G
W W
.ir
SB SB
105
YARIS (EM01V0U)
Cruise Control
(BAT) (IG) (IG)
7. 5A 7. 5A 10A
ECU–B MET ECU–IG
na
2
1 1 4M 24 4B
B
L
16
A25
25 AA2 Junction
Connector
20
B
L
sic
B
30 4B
11 CA2
2 4S
L
D1
B
Combination Meter 2 1
Speed Sensor
IG+
oe
C21
SI SE
CRUISE
5V IC
3 2
W–B
LED Driver
P
12 CA2 13 CA2
CPU
CAN Controller
W–B
P
lec
6 AA2 23 AA2
CAN I/F I/F I/F
W–B
P
20 21 24 16 17 11 AD3
BR
SB
W
G
W
.ir
SB
D3 A1
106
YARIS (EM01V0U)
System Outline
The cruise control system is a constant vehicle speed controller in which control of the switch on the instrument panel makes
it possible to automatically adjust the opening of the engine throttle valve without depressing of the accel pedal.
1. Set Operation
When the CRUISE SW is turned on and the SET SW is pushed with the vehicle speed within the set limit (Approx. 40 km/h,
na
25 mph to 200 km/h, 124 mph), a signal is input to TERMINAL CCS of the engine control module, and the vehicle speed at
the time the SET SW is released is memorized in the ECU as the set speed.
2. Set Speed Control
During cruise control driving, the ECU compares the set speed memorized in the ECU with the actual vehicle speed input
into TERMINAL SPD of the engine control module from the combination meter, and controls the throttle body assembly to
maintain the set speed.
When the actual speed is lower than the set speed, the ECU causes the current to the throttle control motor to flow from
TERMINAL M+ of the engine control module to TERMINAL 2 of the throttle body assembly to TERMINAL 1 to TERMINAL
M– of the engine control module. As a result, the motor in the throttle control motor is rotated to open the throttle valve to
increase the vehicle speed. When the actual driving speed is higher than the set speed, the current to the throttle body
assembly flows from TERMINAL M– of the ECU to TERMINAL 1 of the throttle control motor to TERMINAL 2 to TERMINAL
sic
M+ of the engine control module.
This causes the motor in the throttle body assembly to rotate to close the throttle valve to decrease the vehicle speed.
3. Coast Control
During cruise control driving, while the –SET SW is on, the throttle control motor is rotated to close the throttle valve and
decrease the driving speed. The vehicle speed when the –SET SW is turned off is memorized, and the vehicle continues at
the new set speed.
4. Accel Control
During cruise control driving, while the +RES SW is turned on, the throttle control motor is rotated to open the throttle valve
and increase the driving speed.
The vehicle speed when the +RES SW is turned off is memorized and the vehicle continues at the new set speed.
5. Resume Control
If the vehicle speed is approximately 40 km/h (25 mph) or above after canceling the set speed with the CANCEL SW,
oe
pushing the +RES SW will cause the vehicle to resume the speed set before the cancellation.
6. Manual Cancel Mechanism
If any of the following signals is input during cruise control travelling, the cruise control is cancelled.
∗ Depressing the clutch pedal (Cruise control clutch SW off). ”Signal is not input to TERMINAL D of the ECU” (M/T)
∗ Placing the shift lever to positions except ”D” position (Park/Neutral position SW except ”D” position) (A/T)
∗ Pushing the CANCEL SW (CANCEL SW on). ”Signal input to TERMINAL CCS of the ECU”
∗ Pushing the CRUISE SW off ”signal input to TERMINAL CCS of the ECU”.
∗ Depressing the brake pedal (Stop light SW on)
7. Tap–Up Control Function
When the difference between the actual vehicle speed and the set speed is less than 5 km/h (3 mph), the set speed can be
increased 1.6 km/h (1 mph) each time by operating the +RES SW quickly within 0.6 seconds.
lec
8. Tap–Down Control Function
When the difference between the actual vehicle speed and the set speed is less than 5 km/h (3 mph), the set speed can be
lowered 1.6 km/h (1 mph) each time by operating the –SET SW quickly within 0.6 seconds.
9. Auto Cancel Function
A) If any of the following operating conditions occurs during cruise control operation, the set speed is erased and the cruise
control is released, (CRUISE SW turns off).
When this occurs, the ignition SW must be turned off once before the CRUISE SW will turn on.
∗ When abnormality is found in the stop light SW input circuit.
∗ When abnormality is found in the cancel circuit.
B) If any of the following operating conditions occurs during cruise control operation, the set speed is erased and the cruise
control is released. (CRUISE SW turn off).
When this occurs, the cancel state is cleared as the CRUISE SW will turn on again.
∗ When abnormality is found in electronic throttle parts.
∗ Open circuit in the stop light SW.
.ir
∗ Momentary interruption of vehicle speed signal.
∗ Short circuit in the stop light SW.
107
YARIS (EM01V0U)
Cruise Control
10. Overdrive Control Function

The overdrive control may be cancelled if the vehicle travels on the slope during cruise control travelling. After the overdrive
control has been cancelled it is decided that the slope is finished, the vehicle returns to the overdrive control mode again.
na
: Parts Location
A13 52 (S/D) C20 B 49 (S/D) D15 53 (S/D)
A20 52 (S/D) C21 49 (S/D) D34 53 (S/D)
A21 A 48 (S/D) C27 49 (S/D) D41 53 (S/D)
A25 48 (S/D) C28 49 (S/D) D42 53 (S/D)
A29 52 (S/D) D1 53 (S/D) V1 B 52 (S/D)
C17 49 (S/D) D3 A 53 (S/D)
: Relay Blocks
sic
4C
30
4D
4M
31
4S
oe
AA2 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left)
AD2
AD3 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
AD4
CA1
61 (S/D) Engine Wire and Engine Room Main Wire (Engine Compartment Left)
CA2
: Ground Points
lec
A1 61 (S/D) Left Suspension Tower
C1
61 (S/D) Engine Block Left
C2
D3 63 (S/D) Instrument Panel Reinforcement Left
.ir
108
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
109
YARIS (EM01V0U)
Engine Immobiliser System
(BAT) (IG)
7. 5A 7. 5A
ECU–B IGN
na
2
1 21 4E D24
Transponder Key Amplifier
L
A21 Transponder Key Coil

25 AA2
L
30 4B
IMI IMO EOM VC5 CODE TXCT AGND

11 10 9 1 4 5 7
sic
12 4H
R
P
Junction Connector
BR
W
O
D36(A), D37(B)
11 A
GR
G
P
V
8 AD4 17 AD4 7 AD4
2 B
BR
W
O
L
1 2 13 12 11 14 15 4 5
+B IG EFIO EFII EGND VC5 CODE TXCT AGND
oe
GND IND KSW CTY D
16 8 D23 3 7 9
Transponder Key ECU
LG
W
O
(S/D)
(H/B)
W–B
21
LG
4 4C 6 4C
17 D35
Junction
LG 16 Connector
(S/D) 20
D35
2 Junction 7 4D 21 4A
O
Connector
R
Y
D25
Security 3 4S
Indicator Lamp 1 1
lec
D19 J2
Unlock Door Courtesy SW
Warning SW (Front LH)
7 4E
6 2
W–B
7
W–B
SIL
W–B
5
D40
Junction
Connector D15
11 Data Link
Connector 3
W–B
.ir
3 6A 1 5A
D2 D1
110
YARIS (EM01V0U)
: Parts Location
46 (H/B) 51 (H/B) 51 (H/B)
A21 D24 D37 B
48 (S/D) 53 (S/D) 53 (S/D)
na
51 (H/B) 51 (H/B) 51 (H/B)
D15 D25 D40
53 (S/D) 53 (S/D) 53 (S/D)
51 (H/B) 51 (H/B) 55 (5–Door)
D19 D35
53 (S/D) 53 (S/D) J2 57 (3–Door)
51 (H/B) 51 (H/B) 59 (4–Door)
D23 D36 A
53 (S/D) 53 (S/D)
: Relay Blocks

sic
4C
4D
30
4E Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4H
4S 31
5A 38 Instrument Panel Wire and J/B No.5 (Left Kick Panel)
oe
62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
: Ground Points

62 (H/B)
lec
D1 Left Kick Panel
63 (S/D)
62 (H/B)
D2 Right Kick Panel
63 (S/D)
.ir
111
YARIS (EM01V0U)
(BAT)
7. 5A W
OBD2
J24
na
W
D23 Occupant
Transponder Classification
Key ECU ECU SB
5 4S
W
D DIA L

9 2
Power Steering ECU

7 1 49 41
W
G
CANL CANH CANL CANH
D31
SIL TS TC TACH
A21
7 JD2
2 11 27 15
sic
LG
LG
G
P
D34(A), D35(B)
Junction
12 A Connector 13 A
21 B 20 B
13 AD4
W
31 4E 3 4S 23 4B
oe
7 4E 12 4D
SB
LG
P
L
16 7 12 13 9
BAT SIL TS TC TAC
CG SG CANL CANH
lec
4 5 D15 14 6
BR Data Link Connector 3
(∗1)
5 A
D34(A)
W
V
W–B
(∗2)
Junction
BR
Connector
6 A
BR
(∗1)
6 AD2
BR
V
W–B
W–B
13 CA1
.ir
W
BR
D1 D2 C1
112
YARIS (EM01V0U)
∗ 1 : w/ Cruise Control
∗ 2 : w/o Cruise Control
W W
na
W
SB
L D33
Main Body ECU
CANL CANH
W
22 23
sic
SB
W
W
R
Y
16 5 4 15 11 22
oe
D42 7 18
Junction Connector
W
G
lec
20 21
CANH CANL
D1
Combination Meter
V V
.ir
W W
113
YARIS (EM01V0U)
W
na
W
D16
Airbag Sensor
16 Assembly Center
SIL
CANH CANL
W
13 22
sic
W
W
Y
B
D41
22 11 8 19 Junction Connector
oe
15 4 3 14 6 17 1 12
W
W
G
V
V
L
16 AD4 15 AD4 1 DE1 10 DE1 11 AD4 2 AD4

W
W
G
V
L
lec
2 3 6 5
TX+ TX– CANH CANL
E8 A15
A/C Amplifier Skid Control ECU
with Actuator
W
V
.ir
W
114
YARIS (EM01V0U)
: Parts Location
46 (H/B) 51 (H/B) 51 (H/B)
A15 D23 D41
48 (S/D) 53 (S/D) 53 (S/D)
na
46 (H/B) 51 (H/B) 51 (H/B)
A21 D31 D42
48 (S/D) 53 (S/D) 53 (S/D)
51 (H/B) 51 (H/B) 50 (H/B)
D1 D33 E8
53 (S/D) 53 (S/D) 52 (S/D)
51 (H/B) 51 (H/B) 55 (5–Door)
D15 D34 A
53 (S/D) 53 (S/D) J24 57 (3–Door)
51 (H/B) 51 (H/B) 59 (4–Door)
D16 D35 B
53 (S/D) 53 (S/D)
sic
4D
30
4S 31

62 (H/B)
AD2
63 (S/D)
62 (H/B)
AD4
63 (S/D)
60 (H/B)
oe
61 (S/D)
62 (H/B)
DE1 Instrument Panel Wire and Instrument Panel No.2 Wire (Instrument Panel Center)
63 (S/D)
62 (H/B)
JD2 Floor Wire and Instrument Panel Wire (Instrument Panel Left)
63 (S/D)
: Ground Points

60 (H/B)
61 (S/D)
lec
62 (H/B)
D1 Left Kick Panel
63 (S/D)
62 (H/B)
D2 Right Kick Panel
63 (S/D)
.ir
115
YARIS (EM01V0U)
Multiplex Communication System – CAN
na
D33 D31
Main Body ECU Power Steering ECU
CANL CANH CANH CANL

22 23 1 7
Y
sic
W
SB
W
W
R
Y
16 5 4 15 11 22
oe
D42 7 18
Junction Connector
W
G
lec
20 21
CANH CANL
D1
Combination Meter
.ir
116
YARIS (EM01V0U)
na
D16
Airbag Sensor Assembly Center
CANH CANL
13 22
Y
sic
W
W
W
Y
D41
22 11 8 19 Junction Connector
oe
15 4 3 14 6 17 1 12
W
W
G
V
V
L
16 AD4 15 AD4 1 DE1 10 DE1 11 AD4 2 AD4

lec
W
W
G
V
L
49 41 6 14 2 3 6 5
CANL CANH CANH CANL TX+ TX– CANH CANL
A21 D15 E8 A15

Engine Control Module Data Link Connector 3 A/C Amplifier Skid Control ECU
with Actuator
.ir
117
YARIS (EM01V0U)
Multiplex Communication System – CAN
: Parts Location
46 (H/B) D15 53 (S/D) 51 (H/B)
A15 D41
48 (S/D) 51 (H/B) 53 (S/D)
D16
na
46 (H/B) 53 (S/D) 51 (H/B)
A21 D42
48 (S/D) 51 (H/B) 53 (S/D)
D31
51 (H/B) 53 (S/D) 50 (H/B)
D1 E8
53 (S/D) 51 (H/B) 52 (S/D)
D33
D15 51 (H/B) 53 (S/D)

62 (H/B)
63 (S/D)
62 (H/B)
sic
63 (S/D)
oe
lec
.ir
118
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
119
YARIS (EM01V0U)
Headlight
(BAT) (BAT)
10A 10A
H–LP RH/ H–LP LH/
H–LP LO RH H–LP LO LH
na
2 2
1 1
GR(∗3)
B
GR
GR(∗4)
3 BA1 6 BA1 V(∗4)
L(∗3)
GR
B
3 3 GR(∗3)
sic
B4 B6
Headlamp (RH) Headlamp
(LH)
2 1 2 1
BR
G
L
G
7 BA1 4 BA1 2 BA1 5 BA1

BR
G
(∗3)
(∗3)
V
L
34 4B 16 4B L(∗3)
(∗4)
L
GR(∗3)
oe
16 4C 4 4J
L(∗4)
P
P
(∗1)
GR
(∗2)
P(∗2)
SB
D39
Junction
9 8 7 Connector
5 P(∗1)
HU HL
lec
6
SB
B1 T1 RF (H) ED HU HL (ED) ED
Dimmer SW
Control SW
OFF Flash
Light
(∗1)
BR
Tail Low
Head High
RF ED
D4 12 11
Headlamp Dimmer SW L L
Assembly
12 17
W–B W–B BR(∗1)
4E 4E
.ir
D1
120
YARIS (EM01V0U)
(BAT)
7. 5A ∗ 3 : w/ H–LP/AMT Relay
ECU–B ∗ 4 : w/o H–LP/AMT Relay
na
2
L
GR(∗3) GR(∗3)
GR(∗4)
V(∗4)
L(∗3) L(∗3)
7
GR(∗3) L L
AD5
25 AA2 (∗1 ∗3) (∗1 ∗3)
sic
2 2
L
8 AA2
30 4B 5 1
GR
H–LP/AMT
Relay
20 AD3
2 4S 12 4H 3 2
(∗1)
GR
P
L
14 B (H/B)
14 C (S/D) 2 A 2 2
V(∗4)
W–B
(∗3)
(∗3)
V
oe
D1(A), D2(B), D76(C)
Combination Meter
Head (USA)
Beam
L(∗4) 17 4B
11 B 13 B (H/B)
11 C 13 C (S/D)
35 4B 3 4J
L
P(∗2)
(∗4)
Y
L
P(∗1)
lec
6
SB SB 1
D40
18 B Junction
D37(B) Connector
Junction
Connector
16 B 17 B L
(∗1 ∗3)
P(∗1)
(∗1)
P
L
L P(∗1)
BR(∗1) BR(∗1)
.ir
A1
121
YARIS (EM01V0U)
Headlight
(BAT) (IG)
∗ 3 : w/ H–LP/AMT Relay
15A 10A
FR FOG ECU–IG
na
9 4M 7 4S
V
D4
LFG BFG
V
Fog Light OFF
SW 2 5
D46
Front Fog
sic
Front
R
Light Relay
Junction Connector
LFG BFG
4 3 1 3
8 B
D37(B)
O
R
Y
9 B
GR
D9
16 Running Light Relay 12
FOG IG
oe
DRL +B H HI E PKB CHG–
1 3 7 8 2 11 9
(∗1 ∗3)
W–B
(∗1)
(∗1)
(∗1)
BR
LG
G
R
P
L
13
Connector
Junction Connector
Junction
D36(A), D37(B)
D39
4 B
5 4C 12
L
11 A
lec
2 4C
6 AD5 15 AD3
Y
7 AA2
Parking Brake SW
L 1
(∗1 ∗3)
L
P(∗1)
D21
4 CA1
P(∗1)
BR(∗1)
W–B
L
.ir
4
L
Generator
C9
A1
122
YARIS (EM01V0U)
: Parts Location
46 (H/B) 51 (H/B) D37 B 53 (S/D)
B4 D4
48 (S/D) 53 (S/D) 51 (H/B)
D39
na
46 (H/B) 51 (H/B) 53 (S/D)
B6 D9
48 (S/D) 53 (S/D) 51 (H/B)
D40
47 (H/B) 51 (H/B) 53 (S/D)
C9 D21
49 (S/D) 53 (S/D) 51 (H/B)
D46
51 (H/B) 51 (H/B) 53 (S/D)
D1 A D36 A
53 (S/D) 53 (S/D) D76 C 53 (S/D)
D2 B 51 (H/B) D37 B 51 (H/B)
: Relay Blocks

sic
2 28 Engine Room R/B No.2 (Engine Compartment Right)
4C
4E
30
4H
4J
4M
31
4S
oe
62 (H/B)
63 (S/D)
62 (H/B)
AD3
63 (S/D)
62 (H/B)
AD5
63 (S/D)
60 (H/B)
BA1 Engine Room No.2 Wire and Engine Room Main Wire (Engine Compartment Left)
61 (S/D)
lec
60 (H/B)
61 (S/D)
: Ground Points

60 (H/B)
61 (S/D)
62 (H/B)
D1 Left Kick Panel
63 (S/D)
.ir
123
YARIS (EM01V0U)
2
1
124
W–B G
(S/D) (S/D)
Turn
B14
Turn Signal,
Side Marker and A24(A), B13(B)
Parking Lamp (RH) Junction Connector
2
1
2
1
W–B W–B G G
3 B
4 A
IG
31 4B
B1
LR
(IG)
(H/B) (H/B)
B1
Turn Signal Lamp
10A
(Front RH)
W–B
GAUGE
3 A
2
1
W–B LG (H/B)
(S/D) (S/D)
Turn
na
4
2
B15 R
1
32 4B
+B
Turn Signal,
(BAT)
Side Marker and

Parking Lamp (LH)
10A
HAZ
2
1
3
W–B LG LG
5 B
1 A
LL
14 4B
(H/B) (H/B)
B8
Turn Signal Lamp
(Front LH)
2 A
Turn Signal and Hazard Warning Light
sic
2
1
W–B W–B LG
A1
(H/B) (H/B) (H/B)
A2
FLASH Relay
Turn Signal Lamp (Front Side LH)
YARIS (EM01V0U)
2
1
W–B G
(H/B) (H/B)
A1
Turn Signal Lamp (Front Side RH)
oe
W–B Y
J1
28 4A
Turn
6 B (H/B)
6 A (S/D)
3 B (H/B)
2 A (S/D)
J3(B), J34(A)
W–B LG
J2
27 4A
Turn
lec
6 B (H/B)
6 A (S/D)
3 B (H/B)
J4(B), J35(A) 2 A (S/D)
.ir
na
7
E
E TR TL
Signal SW
RH
Turn
LH
TR TL
W–B
D4 6 5
Headlamp Dimmer SW
Assembly
B
sic
12 4S 11 4S 28 4E
6 5
ER EL
FLASH Relay
EHW GND
8 7
16 4S 13 4S 17 4S 7 4M 17 4E
oe
BR
LG
15 B 8 B (H/B) 15 A (S/D)
15 C 8 C (S/D) 4 B (H/B)
Hazard Warning
D7(B), D77(A)
Signal SW
Turn RH
Turn LH
4 A (S/D)
1 B (H/B)
D1(A), D2(B), D76(C)
Combination Meter
W–B
lec
24 A
W–B
W–B
W–B
W–B
5
Connector
Junction
D40
BR
11
W–B
.ir
3 6A 5 6A 1 6A
D3 D2 D1
125
YARIS (EM01V0U)
Turn Signal and Hazard Warning Light
: Parts Location
A1 46 (H/B) B15 48 (S/D) D76 C 53 (S/D)
A2 46 (H/B) 51 (H/B) D77 A 53 (S/D)
D1 A
na
46 (H/B) 53 (S/D) 55 (5–Door)
A24 A J3 B
48 (S/D) D2 B 51 (H/B) 57 (3–Door)
B1 46 (H/B) 51 (H/B) 55 (5–Door)
D4 J4 B
B8 46 (H/B) 53 (S/D) 57 (3–Door)
46 (H/B) D7 B 51 (H/B) J34 A 59 (4–Door)
B13 B
48 (S/D) 51 (H/B) J35 A 59 (4–Door)
D40
B14 48 (S/D) 53 (S/D)
: Relay Blocks

sic
4E 30
4M Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
31
4S
: Ground Points
oe
A1 60 (H/B) Left Suspension Tower
60 (H/B)
B1 Radiator Support Left
61 (S/D)
62 (H/B)
D1 Left Kick Panel
63 (S/D)
62 (H/B)
D2 Right Kick Panel
63 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
lec
J1 65 (3–Door)
64 (5–Door)
Left Rear Quarter Panel
J2 65 (3–Door)
66 (4–Door) Lower Back Panel Left
.ir
126
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
127
YARIS (EM01V0U)
K1
128
Map Lamp
1
2
L L L
5 4K
13 4B
(BAT)
2
W–B 15A
DOME
Interior Light
K2
Room Lamp (Center)
3
W–B
On
1
Off L
2
P
Door
na
W–B
2
1
GR GR L
10 A
1 B
4 4P
12 JD1
J12 D38(A), D39(B)
Room Lamp (Luggage) Junction
Connector
sic
O
23
SB
6 B
7 4A
YARIS (EM01V0U)
BCTY(H/B)
LGCY(S/D)
1
2
W
2 A
5 B
oe
J30 J28(A), J29(B)
Diode (Room Lamp) Junction
D33(A)
Connector
BR
BR
(H/B)
(S/D)
Main Body ECU
Courtesy
1
2
W–B BR BR
N1
12 MJ1
15 MN1
(H/B) (H/B) (H/B)

N2
Back Door
Courtesy SW
Courtesy
2
3
W–B BR
J2
(S/D) (S/D)
lec
J42
P
Door Lock Assembly W–B

(Luggage)
.ir
(ACC) (BAT)
7. 5A 25A
ACC D/L
na
D33(A)
21 4 Main Body ECU
ACC ALTB
ILE GND1 KSW CANH CANL

7 1 9 23 A 22 A
sic
7 4D
2 4K 1 4K 17 4E
Y
W–B
W–B
W
R
P
5 16
D42
Junction Connector
7 18
oe
W
G
Unlock Warning SW
1
D19
P
W–B
lec
W–B
W
1 5A
.ir
G
W–B
D1 D1
129
YARIS (EM01V0U)
Interior Light
(BAT)
7. 5A
ECU–B
na
2
1
25
L L L
AA2
30 4B 2 4S
D33(A)
Main Body ECU 6
BECU
DCTY PCTY RRCY

26 20 22
sic
21 4A 24 4A 20 4A 5 4A
Y
R
(∗3)
(∗4)
(∗4)
G
L
L
oe Door Courtesy SW (Front RH)
Door Courtesy SW (Front LH)
Door Courtesy SW (Rear RH)
Door Courtesy SW (Rear LH)
1 1 1 1
J32
J33
J2
J1
(∗3)
(∗3)
G
L
Y(∗3)
lec
G(∗3)
L(∗3)
W W
.ir
G G
130
YARIS (EM01V0U)
∗ 1 : S/D w/ Tachometer
∗ 2 : S/D w/o Tachometer, H/B
(IG) ∗ 3 : S/D ∗5
∗ 4 : H/B, S/D Except ∗5
7. 5A w/ Engine Immobiliser System,
MET w/ ABS,
na
1 4M
L L w/ Air Conditioning
B
D1(A), D76(C)
Combination Meter 2 A 1 A
(∗2)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
sic
(Front RH)
(Rear RH)
(Front LH)
(Luggage)
(Rear LH)
Graphic
Door
Door
Door
Door
Door
Door
Door
(∗1)
(∗1)
(∗2)
(∗1)
(∗1)
(∗1)
(∗1)
LED Driver
CPU
CAN Controller
oe
CAN I/F
22 C 20 C 21 C 21 A 20 A 24 A
(∗3)
(∗3)
(∗3)
G
Y
BR
W
5 JD2 2 JD2 3 JD2
Y(∗3)
lec
G(∗3)
L(∗3)
W
.ir
G
D3
131
YARIS (EM01V0U)
Interior Light
: Parts Location
51 (H/B) J1 59 (4–Door) J30 59 (4–Door)
D1 A
53 (S/D) 55 (5–Door) 55 (5–Door)
J32
na
51 (H/B) J2 57 (3–Door) 59 (4–Door)
D19
53 (S/D) 59 (4–Door) 55 (5–Door)
J33
51 (H/B) 55 (5–Door) 59 (4–Door)
D33 A
53 (S/D) J12 57 (3–Door) J42 59 (4–Door)
51 (H/B) 59 (4–Door) 54 (5–Door)
D38 A
53 (S/D) 55 (5–Door) K1 56 (3–Door)
51 (H/B) J28 A 57 (3–Door) 58 (4–Door)
D39 B
53 (S/D) 59 (4–Door) 54 (5–Door)
51 (H/B) 55 (5–Door) K2 56 (3–Door)
D42
53 (S/D) J29 B 57 (3–Door) 58 (4–Door)
D76 C 53 (S/D) 59 (4–Door) 54 (5–Door)
N2
sic
55 (5–Door) 55 (5–Door) 56 (3–Door)
J1 J30
57 (3–Door) 57 (3–Door)
: Relay Blocks

oe
4D
4E
4K 30 Roof Wire and Instrument Panel J/B (Lower Finish Panel)
4M
4P 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4S

62 (H/B)
lec
63 (S/D)
62 (H/B)
JD1
63 (S/D) Floor Wire and Instrument Panel Wire (Instrument Panel Left)
JD2 63 (S/D)
64 (5–Door)
MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel)
65 (3–Door)
64 (5–Door)
MN1 Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center)
65 (3–Door)
.ir
132
YARIS (EM01V0U)
: Ground Points

62 (H/B)
D1 Left Kick Panel
63 (S/D)
na
62 (H/B)
63 (S/D)
J2 66 (4–Door) Lower Back Panel Left
64 (5–Door)
N1 Back Door Panel Center
65 (3–Door)
sic
oe
lec
.ir
133
YARIS (EM01V0U)
Taillight and Illumination
B
(BAT)
1 4G
120A ALT
(∗1)
A28
Fusible
Link Block
na
(∗1)
(∗1)
1
10A
TAIL T–LP
Relay
(∗1)
(∗1)
(∗1)
(∗1)
4 4M 9 4S 19
TRLY
(∗2)
(∗1)
W
W
sic
Main Body ECU
G
13 (∗2)
B1
B1 T1
Light OFF
Control
SW Tail
G
Head
(S/D)
D4
T1 G
10 (S/D)
oe
G G
(∗2) (S/D)
G
(S/D)
Turn Signal, Side Marker and
(S/D)
(S/D)
(S/D)
(S/D)
G
4 3 4 3
Parking Lamp (RH)
Parking Lamp (LH)

Side Marker and
Parking
Parking
Marker
Marker
Turn Signal,
Side
Side
B14
B15
lec
2 2
(S/D)
(S/D)
W–B
W–B
W–B
(∗1)
W–B
(S/D)
∗ 1 : H/B, S/D ∗3
∗ 2 : Except ∗1
.ir
w/ ABS,
4 6A
D2 w/ Air Conditioning
134
YARIS (EM01V0U)
G
G
G
G
G
(∗2)
(∗1)
W–B
(S/D)
(S/D)
(S/D)
(S/D)
(S/D)
1
2
W–B G
9 B
(H/B) (H/B)
B11
Side Marker Lamp
(Front RH) G
W–B
10 4E
(∗2)
1
2
W–B W–B W–B G
10 B
10 A
A1
8 BA1
(H/B) (H/B)
B12
Side Marker Lamp
GR
(Front LH)
W–B
2
1
W–B W–B G
7 B
11 A
B1
(H/B) (H/B)
B3
na
Parking Lamp (RH)
2
1
W–B G P
8 B
12 A
33 4B
(H/B) (H/B)
B7 A24(A), B13(B)
Parking Lamp (LH) Junction Connector
10A
7. 5A
TAIL(∗1)
Tail
PANEL2(∗2)
W–B GR
J1
10 4A
6 B (H/B)
6 A (S/D)
4 B (H/B)
4 A (S/D)
J3(B), J34(A)
sic
YARIS (EM01V0U)
Tail
W–B W–B G G
J2
29 4A
6 B (H/B)
6 A (S/D)
4 B (H/B)
4 A (S/D)
J4(B), J35(A)
oe
1
2
W–B W–B G G
G
9 LJ1
4 LJ1
(S/D)
(H/B) (H/B) (H/B) (H/B)

L1
License Plate Lamp
W–B
(S/D)
1
2
W–B G
(S/D) (S/D)
J36
License Plate
Lamp (RH)
1
2
W–B G
(S/D) (S/D)
J37
lec
License Plate
Lamp (LH)
135
.ir
BR
(IG)
6 4Q 10 4P
na
7. 5A 7. 5A
PANEL1 MET
7 4P 1 4M 2 4Q 9 4Q
SB(H/B)
R
R(H/B) R(H/B)
R
(S/D)
sic
(S/D)
R
5
G
DE1 13
Hazard Warning Signal SW

G
E10
20 Junction Connector
G
G
B
19 21 22
D77
3
(S/D)
GR
Rear Window Defogger SW
W
B
L
oe
16 B (H/B)
16 C (S/D) 1 A 14 A 2 5 5
Blower SW
A/C SW
(S/D)
E1
E6
E5
Pointer
Dial
1 4 6
R
Tail (Canada)
Illumination I/F
8 DE1
lec D1(A), D2(B), D76(C)
I/F
Combination Meter
LG
CPU
I/F 11 10 8 9
24 A 15 A 7 A E10
Junction Connector
GR
BR
GR
Y
.ir
D3
136
YARIS (EM01V0U)
Y
V
R
W
BR
GR
(S/D)
R(H/B)
SB(H/B)
2
3
W W R
(H/B) (H/B)
D7
D38(A), D39(B) Hazard Warning Signal SW
Junction
Connector
LG
16 B
2
ILL–
7
ILL+
W SB
(H/B) (H/B)
16 A
17 B
D30
Door Lock Control SW
1
2
W G
na
18 A
18 B
D20
A/T Shift Lever Illumination
8 B
G G V
5 B
10 A
2 A
9 B
ILL–
ILL+
D10(A), D11(B)
11 B
Radio Receiver Assembly

D38(A), D39(B)
sic
Junction Connector
9
4
2
11
W–B W B
3 6A
D2
DIM
ILL–
(H/B) (H/B) (H/B)
D40
YARIS (EM01V0U)
Junction Connector D27
Passenger Seat Belt Warning Lamp
3 6A
2
5
LG BR
T
RV
W–B
oe
D29
9
W O
20 B
15 A
RL
D36(A), D37(B)
Junction Connector
Light Control Rheostat
Y
TC
10A
GAUGE
3
10
W–B SB
lec
E
IG
1 4P
(IG)
137
.ir
: Parts Location
46 (H/B) D10 A 53 (S/D) D77 53 (S/D)
A24 A
48 (S/D) 51 (H/B) 50 (H/B)
D11 B E1
na
43, 46 (H/B) 53 (S/D) 52 (S/D)
A28
43, 48 (S/D) 51 (H/B) 50 (H/B)
D20 E5
B3 46 (H/B) 53 (S/D) 52 (S/D)
B7 46 (H/B) D27 51 (H/B) 50 (H/B)
E6
B11 46 (H/B) 51 (H/B) 52 (S/D)
D29
B12 46 (H/B) 53 (S/D) 50 (H/B)
E10
46 (H/B) D30 51 (H/B) 52 (S/D)
B13 B
48 (S/D) 51 (H/B) 55 (5–Door)
D36 A J3 B
B14 48 (S/D) 53 (S/D) 57 (3–Door)
B15 48 (S/D) 51 (H/B) 55 (5–Door)
D37 B J4 B
51 (H/B) 53 (S/D) 57 (3–Door)
D1 A
sic
53 (S/D) 51 (H/B) J34 A 59 (4–Door)
D38 A
D2 B 51 (H/B) 53 (S/D) J35 A 59 (4–Door)
51 (H/B) 51 (H/B) J36 59 (4–Door)
D4 D39 B
53 (S/D) 53 (S/D) J37 59 (4–Door)
D7 51 (H/B) D40 51 (H/B) 54 (5–Door)
L1
D10 A 51 (H/B) D76 C 53 (S/D) 56 (3–Door)
4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
oe
4M
4P
4Q
4S

60 (H/B)
lec
61 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
LJ1 Luggage Room No.2 Wire and Floor Wire (Luggage Room Left)
65 (3–Door)
.ir
138
YARIS (EM01V0U)
: Ground Points

60 (H/B)
61 (S/D)
na
60 (H/B)
61 (S/D)
62 (H/B)
D2 Right Kick Panel
63 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
J1 65 (3–Door)
64 (5–Door)
J2 65 (3–Door)
sic
oe
lec
.ir
139
YARIS (EM01V0U)
Back–Up Light
(IG)
10A
GAUGE
na
19 4B
G
1 CA1
G
sic
J28(A), J29(B)
9 B Junction Connector
10 A 9 A
(M/T)
(A/T)
BR
G
R
oe

5 A (S/D) 5 A (S/D)
2 2 1 B (H/B) 1 B (H/B)
C22
J3(B), J34(A)
J4(B), J35(A)
Back–Up Lamp SW
Back–Up
Back–Up
RB RL
R
C27
1 1 6 A (S/D) 6 A (S/D)
6 B (H/B) 6 B (H/B)
(M/T)
(A/T)
W–B
W–B
R
lec
30 4A
3 CA1
22 4B
R
.ir
J1 J2
140
YARIS (EM01V0U)
: Parts Location
47 (H/B) 55 (5–Door) 57 (3–Door)
C22 J4 B J29 B
49 (S/D) 57 (3–Door) 59 (4–Door)
na
47 (H/B) 55 (5–Door) J34 A 59 (4–Door)
C27
49 (S/D) J28 A 57 (3–Door) J35 A 59 (4–Door)
55 (5–Door) 59 (4–Door)
J3 B
57 (3–Door) J29 B 55 (5–Door)

sic
60 (H/B)
61 (S/D)
: Ground Points

64 (5–Door)
J1 65 (3–Door)
64 (5–Door)
J2 65 (3–Door)
oe
lec
.ir
141
YARIS (EM01V0U)
Stop Light
∗ 1 : S/D LED Type
(BAT) ∗ 2 : S/D Bulb Type
10A
STOP
na
18 4B
B
2
A13
Stop Lamp SW
1
sic
O
G
(S/D)
O
12 4B (H/B)
(∗1)
(∗2)
O
O
10 MJ1
12 4A
(S/D)
(H/B)
O
2 A (∗1)
Center Stop Lamp
Center Stop Lamp

1 B (H/B) 1
V
M1(B), J41(A)
J28(A), J29(B)
oe
3 B Junction Connector 4 B
J40
1 A (∗1)
2 B (H/B) 2
3 A 4 A
(H/B)
W–B
W–B
W–B
(∗1)
(∗2)
O
V

1 A (S/D) 1 A (S/D)
5 B (H/B) 5 B (H/B)
lec
J4(B), J35(A)
J3(B), J34(A)
Stop
Stop
6 A (S/D) 6 A (S/D) 11 MJ1

6 B (H/B) 6 B (H/B)
W–B
W–B
W–B(H/B)
W–B(S/D)
.ir
W–B
W–B
J2 J1
142
YARIS (EM01V0U)
: Parts Location
50 (H/B) 55 (5–Door) J34 A 59 (4–Door)
A13
52 (S/D) J28 A 57 (3–Door) J35 A 59 (4–Door)
na
55 (5–Door) 59 (4–Door) J40 59 (4–Door)
J3 B
57 (3–Door) 55 (5–Door) J41 A 59 (4–Door)
55 (5–Door) J29 B 57 (3–Door) 54 (5–Door)
J4 B M1 B
57 (3–Door) 59 (4–Door) 56 (3–Door)

sic
64 (5–Door)
65 (3–Door)
: Ground Points

64 (5–Door)
J1 65 (3–Door)
64 (5–Door)
J2 65 (3–Door)
oe
lec
.ir
143
YARIS (EM01V0U)
Horn
(BAT)
10A
HORN
na
2
HORN
Relay
7 1A 8 1A
LG
G
sic
28 4B 17 AA2
G
18 4E
1 BA1
oe
G
B
8 A
HO D3(A), V1(B), (C)
Spiral Cable
lec
2 B (S/D)
1 C (H/B) 1
B2
W
Horn
V1(B), (C)
Horn Steering Pad SW
SW
.ir
144
YARIS (EM01V0U)
: Parts Location
46 (H/B) 51 (H/B) B 52 (S/D)
B2 D3 A V1
48 (S/D) 53 (S/D) C 50 (H/B)
na

62 (H/B)
63 (S/D)
sic
60 (H/B)
61 (S/D)
oe
lec
.ir
145
YARIS (EM01V0U)
Front Fog Light
na
D4
LFG BFG
Fog Light OFF

SW
sic
Front
LFG BFG
4 3
Y
(∗1)
O
16
D9
FOG Running Light
Relay
(∗2)
H HI W
7 8
oe (∗1)
(∗1)
(∗1)
GR
BR
16 4C
P
17 6 2
Connector
Connector
D40
Junction
Junction
Junction
D37
D39
4 4J Connector
16 7 1
(∗1)
(∗1)
(∗2)
SB
P
L
12 9 8
RF HU HL
lec
Dimmer SW
Control SW
OFF Flash
Light
Tail Low
Head High
ED
D4 11
Headlamp Dimmer SW
Assembly
12 17
W–B W–B
4E 4E
.ir
D1
146
YARIS (EM01V0U)
(BAT)

15A ∗ 2 : w/o Daytime Running Light
FR FOG
na
9 4M
V
V
2 5
D46
Front Fog Light Relay
sic
1 3
Y R
7 AD2
R
R
oe
7 B (H/B)
7 C (S/D) 6 A
A24(A), B13(B)
Junction Connector
Front
Fog
2 B 1 B
(S/D)
D1(A), D2(B), D76(C)

Combination Meter
(H/B)
R
(S/D)
lec
2 2
B10 B9
24 A Fog Lamp (Front LH) Fog Lamp (Front RH)
1 1
W–B
W–B
.ir
W–B
BR
D3 B1
147
YARIS (EM01V0U)
Front Fog Light
: Parts Location
46 (H/B) 51 (H/B) D37 53 (S/D)
A24 A D1 A
48 (S/D) 53 (S/D) 51 (H/B)
D39
na
46 (H/B) D2 B 51 (H/B) 53 (S/D)
B9
48 (S/D) 51 (H/B) 51 (H/B)
D4 D40
46 (H/B) 53 (S/D) 53 (S/D)
B10
48 (S/D) 51 (H/B) 51 (H/B)
D9 D46
46 (H/B) 53 (S/D) 53 (S/D)
B13 B
48 (S/D) D37 51 (H/B) D76 C 53 (S/D)
4C
4E 30
sic
4J
4M 31

62 (H/B)
63 (S/D)
: Ground Points

60 (H/B)
oe
61 (S/D)
62 (H/B)
D1 Left Kick Panel
63 (S/D)
62 (H/B)
63 (S/D)
lec
.ir
148
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
149
YARIS (EM01V0U)
Front Fog Light
na
D4
LFG BFG
Fog Light OFF

SW
sic
Front
LFG BFG
4 3
Y
(∗1)
O
16
D9
FOG Running Light
Relay
(∗2)
H HI W
7 8
oe (∗1)
(∗1)
(∗1)
GR
BR
16 4C
P
17 6 2
Connector
Connector
D40
Junction
Junction
Junction
D37
D39
4 4J Connector
16 7 1
(∗1)
(∗1)
(∗2)
SB
P
L
12 9 8
RF HU HL
lec
Dimmer SW
Control SW
OFF Flash
Light
Tail Low
Head High
ED
D4 11
Headlamp Dimmer SW
Assembly
12 17
W–B W–B
4E 4E
.ir
D1
146
YARIS (EM01V0U)
(BAT)

FR FOG
na
9 4M
V
V
2 5
D46
sic
1 3
Y R
7 AD2
R
R
oe
7 B (H/B)
7 C (S/D) 6 A
A24(A), B13(B)
Junction Connector
Front
Fog
2 B 1 B
(S/D)
D1(A), D2(B), D76(C)

Combination Meter
(H/B)
R
(S/D)
lec
2 2
B10 B9
24 A Fog Lamp (Front LH) Fog Lamp (Front RH)
1 1
W–B
W–B
.ir
W–B
BR
D3 B1
147
YARIS (EM01V0U)
Front Fog Light
: Parts Location
46 (H/B) 51 (H/B) D37 53 (S/D)
A24 A D1 A
48 (S/D) 53 (S/D) 51 (H/B)
D39
na
46 (H/B) D2 B 51 (H/B) 53 (S/D)
B9
48 (S/D) 51 (H/B) 51 (H/B)
D4 D40
46 (H/B) 53 (S/D) 53 (S/D)
B10
48 (S/D) 51 (H/B) 51 (H/B)
D9 D46
46 (H/B) 53 (S/D) 53 (S/D)
B13 B
48 (S/D) D37 51 (H/B) D76 C 53 (S/D)
4C
4E 30
sic
4J
4M 31

62 (H/B)
63 (S/D)
: Ground Points

60 (H/B)
oe
61 (S/D)
62 (H/B)
D1 Left Kick Panel
63 (S/D)
62 (H/B)
63 (S/D)
lec
.ir
148
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
149
YARIS (EM01V0U)
ABS
(IG)
7. 5A
MET
na
1 4M
B
1 A
Brake (Canada)
BRAKE (USA)
sic
ABS
LED Driver
CPU
D1(A), D2(B), D76(C)

Combination Meter
CAN Controller
CAN I/F
oe
2 B (H/B) 24 A 20 A 21 A
2 C (S/D)
BR
W
G
V
7 18
Connector
Junction
Connector 3
D42
Data Link
11 22
D15
TC
13
W
Y
18 AD3
lec
11 22
Connector
Junction
P
D41
V
4 1 15 12
19 AA2 W
W
L
12 4D
G
V
Level Warning SW
1 23 4B
15 AD4 16 AD4
Brake Fluid
A10
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
SB
W
G
R
R
P
V
L
2
.ir
27 A 41 A 49 A 73 B 53 B 54 B 55 B 74 B
W–B
TC CANH CANL P R N 2 L
A1 D3 A21(A), C20(B)
154
YARIS (EM01V0U)
(IG) (BAT) (BAT) (BAT)
10A 10A 30A 50A

ECU–IG STOP ABS2/ ABS1/
VSC2 VSC1
na
2 2
24 4B 18 4B 1 1
W
B
B
B
2
16
Connector
A13
Junction
Stop
A25
Lamp SW
19
1
sic B
A11 A7
Speed Sensor Speed Sensor
(Front LH) (Front RH)
12 4B 2 1 2 1
1 AA1 8 AA1 7 AA1
21 4B
W
G
G
R
B
B
25 10 9 8 31 30 1 23
oe
IG1 STP FL+ FL– FR+ FR– +BS +BM
A15
Skid Control ECU with Actuator
CANL CANH RL– RL+ RR– RR+ GND1 GND2

5 6 12 11 34 33 2 24
W–B
W–B
LG
W
2 AD4 11 AD4 11 AJ1 10 AJ1 9 AJ1 8 AJ1

lec
LG
B
G
2 aJ1 1 aJ1 2 ZJ1 1 ZJ1
BR 1 2 W BR 1 2 W
W–B
a1 Z1
(Rear LH) (Rear RH)
.ir
A2
155
YARIS (EM01V0U)
ABS
System Outline
1. Speed Sensor
Detects the wheel speed of each of four wheels.
2. Skid Control ECU
Based on signals from the sensors, it judges the vehicle driving condition and sends the brake control signal to the brake
na
actuator.
3. ABS Warning Light
Lights up to alert the driver when the ECU detects a malfunction in the ABS system and stopps the system.
4. Brake Warning Light
Lights up simultaneously with the ABS warning light to alert the driver when the ECU detects a malfunction not only in the
ABS but also in the EBD. Single light–up of the brake warning light alerts the driver when the ECU detects a malfunction in
the brake system.
5. Engine Control Computer
Sends signals such as park/neutral position SW, TC switch, etc., to the skid control ECU with actuator.
sic
: Parts Location
46 (H/B) A21 A 48 (S/D) D41 53 (S/D)
A7
48 (S/D) 46 (H/B) 51 (H/B)
A25 D42
46 (H/B) 48 (S/D) 53 (S/D)
A10
48 (S/D) 47 (H/B) D76 C 53 (S/D)
C20 B
46 (H/B) 49 (S/D) 54 (5–Door)
A11
48 (S/D) 51 (H/B) Z1 56 (3–Door)
D1 A
50 (H/B) 53 (S/D) 58 (4–Door)
A13
52 (S/D) D2 B 51 (H/B) 54 (5–Door)
46 (H/B) 51 (H/B) a1 56 (3–Door)
A15 D15
oe
48 (S/D) 53 (S/D) 58 (4–Door)
A21 A 46 (H/B) D41 51 (H/B)
: Relay Blocks

lec
4D 30
4M 31
.ir
156
YARIS (EM01V0U)
62 (H/B)
AA1
63 (S/D)
na
62 (H/B)
AA2
63 (S/D)
62 (H/B)
AD3
63 (S/D)
62 (H/B)
AD4
63 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
ZJ1 65 (3–Door) Skid Control Sensor RH Wire and Floor Wire (Quarter Wheel House Panel RH)
66 (4–Door)
sic
64 (5–Door)
aJ1 65 (3–Door) Skid Control Sensor LH Wire and Floor Wire (Quarter Wheel House Panel LH)
66 (4–Door)
: Ground Points

60 (H/B)
A1
61 (S/D)
Left Suspension Tower
60 (H/B)
A2
61 (S/D)
62 (H/B)
63 (S/D)
oe
lec
.ir
157
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
158
YARIS (EM01V0U)
SRS
NOTICE: When inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions
and the procedure, and precautions in the Repair Manual applicable for the model year.
D Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most important source of information
when troubleshooting. When troubleshooting the SRS, always inspect the DTCs before disconnecting the battery.
na
D Work must be started more than 90 seconds after the ignition SW is turned to the ”LOCK” position and the
negative (–) terminal cable is disconnected from the battery.
(The SRS is equipped with a back–up power source so that if work is started within 90 seconds from
disconnecting the negative (–) terminal cable of the battery, the SRS may deploy.)
D When the negative (–) terminal cable is disconnected from the battery, the memory of the clock and audio system will be
cleared. So before starting work, make a record of the contents in the audio memory system. When work is finished,
reset the audio systems as they were before and adjust the clock. Some vehicles have power tilt steering, power
telescopic steering, power seat and power outside rear view mirror which are all equipped with memory function.
However, it is not possible to make a record of these memory contents. So when the work is finished, it will be
necessary to explain it to your customer, and ask the customer to adjust the features and reset the memory. To avoid
erasing the memory in each system, never use a back–up power supply from outside the vehicle.
sic
D Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair.
D Do not expose the following parts directly to hot air or flame;
D Even in cases of a minor collision where the SRS does not deploy, the following parts should be inspected;
D Never use SRS parts from another vehicle. When replacing parts, replace with new parts.
D For the purpose of reuse, never disassemble and repair the following parts.
D If the following parts have been dropped, or have cracks, dents and other defects in their case, bracket, and connector,
replace with new one.
D Use a volt/ohmmeter with high impedance (10 kΩ/V minimum) for troubleshooting electrical circuits of the system.
oe
D Information labels are attached to the periphery of the SRS components. Follow the instructions of the notice.
D After work on the SRS is completed, check the SRS warning light.
D If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the Repair
Manual.
∗ Steering wheel pad

∗ Front passenger airbag assembly
∗ Side airbag assembly
∗ Curtain shield airbag assembly
∗ Seat belt pretensioner
lec
∗ Center airbag sensor assembly
∗ Front airbag sensor assembly
∗ Side airbag sensor assembly
∗ Rear airbag sensor assembly
.ir
159
YARIS (EM01V0U)
SRS
(IG)
7. 5A
IGN
na
16 4E
A6 A12
Airbag Sensor Airbag Sensor
(Front RH) (Front LH)
+SR –SR +SL –SL

2 1 2 1
sic
W
W
B
B
1 AD1 2 AD1 3 AD1 4 AD1
W
W
B
B
oe
D16(A), J8(C), J9(B)
21 A Airbag Sensor Assembly Center 29 A 27 A 30 A 28 A
IG2 +SR –SR +SL –SL
E2 E1 PD+ PD– PP+ PP– P+ P– P2+ P2–

26 A 25 A 2 C 1 C 4 B 5 B 4 A 3 A 1 A 2 A
lec
W–B
W–B
Y–G
Y–R
Y–B
Y–B
Y–B
Y
14 4E 30 4E 1 DQ1 2 DQ1 3 DQ1 4 DQ1

Y–G
Y–R
Y–B
17 4E 2 1 2 1 2 A 1 A 2 B 1 B
J21 J20 Q1(A), Q2(B)

Pretensioner Pretensioner Airbag Squib
(LH) (RH) (Front Passenger' s Airbag Assembly)
W–B
.ir
D1
160
YARIS (EM01V0U)
na
J15 J14
Airbag Sensor (Rear LH) Airbag Sensor (Rear RH)
BCL+ BCL– BCR+ BCR–

2 1 2 1
sicR
R
B
B
1 2 1 2
BCL+ BCL– J17 BCR+ BCR– J16
Side Airbag Sensor (LH) Side Airbag Sensor (RH)
BBL+ BBL– BBR+ BBR–
4 3 4 3
R
R
L
L
oe
D16(A), J8(C), J9(B)
8 C 15 C 8 B 11 B Airbag Sensor Assembly Center
BBD+ BBD– BBP+ BBP–
SFP+ SFP– SFD+ SFD– ICP+ ICP– ICD+ ICD–

7 B 6 B 9 C 10 C 9 B 10 B 7 C 6 C
lec
Y–R
Y–B
Y–B
Y–B
Y–B
Y
2 JX1 1 JX1 2 JY1 1 JY1

Y–B
Y–B
Y
2 1 2 1 1 2 1 2
X1 Y1 J22 J23
Side Airbag Squib (RH) Side Airbag Squib (LH) Curtain Shield Airbag Curtain Shield
Squib (RH) Airbag Squib (LH)
.ir
161
YARIS (EM01V0U)
SRS
(IG) (IG)
D33 D1
Main Body ECU Combination Meter
7. 5A 10A
MET GAUGE
na
Airbag
CANL CANH 1 4M 15 4S
22 23 LED Driver
(H/B)
Y
CPU
CAN Controller Y
B
(S/D)
CAN I/F
W
sic R
1 21 20 24
BR
W
G
18 7
D42
Junction
Connector
5 16 22 11
W
W
R
Y
Y(H/B)
22 11
D41
Junction
oe
Connector
BR
19 8
W
22 A 13 A
CANL CANH
D+ D– D2+ D2–
5 A 6 A 8 A 7 A D16(A), J8(C), J9(B)
lec
Y–G
Y–R
Y–B
1 A 2 A 4 A 3 A
D+ D– D2+ D2– D18(A), W1(B), W2(C)
Spiral Cable
2 B 1 B 2 C 1 C
W1(B), W2(C)
Airbag Squib
(Steering Wheel Pad)
.ir
162
YARIS (EM01V0U)
J24(A), U1(B)
D77 Occupant Classification ECU
Passenger' s Seat Belt/Airbag Indicator (ON/OFF)

na
IG+ P–AB PAON FSR+ FSR–
6 10 9 8 A 4 A
(S/D)
(S/D)
GR
GR
R
Y
Y
(S/D)
D27
sic
Passenger' s Seat Belt/Airbag

Indicator (ON/OFF)
IG+ P–AB PAON
6 5 1
(H/B)
(H/B)
(H/B)
GR
R
Y
14 4S 3 4E
Y(H/B)
32 4E 15 4E W
oe
BR
GR
W
G
B
D16(A), J8(C), J9(B)

Airbag Sensor Assembly Center 17 A 23 A 12 B 13 B 16 A
P–AB PAON FSP+ FSP– SIL
DSP+ DSP– DBE+ DBE–

14 C 13 C 11 C 12 C
lec
Y–R
R
Y
2 1 4 3
LSP+ LSP– LBE+ LBE–
BR
J10
Front Seat Inner Belt (Driver' s Side)
.ir
D3
163
YARIS (EM01V0U)
SRS
J24(A), U1(B)
na
DIA GND BSW BGND SVC1 SIG1 SGD1 SVC3 SIG3 SGD3
2 A 3 A 9 A 5 A 11 B 7 B 1 B 5 B 9 B 3 B
W–B
GR
SB
W
G
G
R
P
Y
7 JD2
2 1 1 2 3 1 2 3
RBE+ RBE– SVC1 SIG1 SGD1 SVC3 SIG3 SGD3
G
sic Junction Connector
J11 U2 U3
D34(A), D35(B)
12 A Front Seat Inner Belt Occupant Classification Occupant Classification

Assembly (Front RH) Sensor (Front LH) Sensor (Rear LH)
20 B
O
3 4S 15 4A
31
W
4E
oe
7 4E 17 4E
W–B
L
lec
7
SIL
D15
Data Link
Connector 3
.ir
D1
164
YARIS (EM01V0U)
J24(A), U1(B)
Occupant Classification ECU (IG) (BAT)
7. 5A 7. 5A
IGN ECU–B
na
SVC2 SIG2 SGD2 SVC4 SIG4 SGD4 +B IG
12 B 8 B 2 B 6 B 10 B 4 B 1 A 7 A 2
1 4D 1
BR
W
O
R
V
V
L
L
6 JD2 1 JD2
25 AA2
1 2 3 1 2 3
SVC2 SIG2 SGD2 SVC4 SIG4 SGD4
O
L
sic
30 4B
U4 U5 8
D36
Occupant Classification Occupant Classification Junction
Sensor (Front RH) Sensor (Rear RH) Connector
11
12 4H
P
oe
lec
.ir
165
YARIS (EM01V0U)
SRS
System Outline
∗ The system reaches an ignition judgment to deploy the following device based on the signals received from the front
airbag sensor and deceleration sensor.
– Driver Airbag
– Front Passenger Airbag
na
– Seat Belt Pretensioner
∗ The system reaches an ignition judgment to deploy the following device based on the signals received from the side
airbag sensors.
– Side Airbags
– Curtain Shield Airbags
∗ The dual–stage SRS airbag system has been used for the driver and front passenger airbags. This system controls the
optimal airbag inflation by judging the extent of impact, seat position (driver seat) and whether or not the seat belt is
fastened(driver seat) and infomation from the Front Passenger Occupant Classification System.
∗ The front passenger occupant classification system judges whether the front passenger seat is occupied by an adult or
child (with child seat) or is unoccupied, according to the load applied to the front passenger seat and whether the seat belt
is buckled. Based on the results, it restricts the deployment of the front passenger airbag, front passenger side airbag, and
front passenger seat belt pretensioner. In addition, the system informs the driver of the result of the judgment through the
use of the AIRBAG ON/OFF indicator lights.
sic
∗ The airbag sensor assembly transmits a signal to the engine control module in order to stop the fuel pump.
∗ The Airbag sensor assembly transmits a signal to the main body ECU in order to release the door lock.
: Parts Location
46 (H/B) 57 (3–Door) J24 A 59 (4–Door)
A6 J10
48 (S/D) 59 (4–Door) 50 (H/B)
Q1 A
46 (H/B) 55 (5–Door) 52 (S/D)
A12
48 (S/D) J11 57 (3–Door) 50 (H/B)
Q2 B
51 (H/B) 59 (4–Door) 52 (S/D)
D1
53 (S/D) 55 (5–Door) 54 (5–Door)
oe
51 (H/B) J14 57 (3–Door) U1 B 56 (3–Door)
D15
53 (S/D) 59 (4–Door) 58 (4–Door)
51 (H/B) 55 (5–Door) 54 (5–Door)
D16 A
53 (S/D) J15 57 (3–Door) U2 56 (3–Door)
51 (H/B) 59 (4–Door) 58 (4–Door)
D18 A
53 (S/D) 55 (5–Door) 54 (5–Door)
D27 51 (H/B) J16 57 (3–Door) U3 56 (3–Door)
51 (H/B) 59 (4–Door) 58 (4–Door)
D33
53 (S/D) 55 (5–Door) 54 (5–Door)
51 (H/B) J17 57 (3–Door) U4 56 (3–Door)
D34 A
53 (S/D) 59 (4–Door) 58 (4–Door)
lec
51 (H/B) 55 (5–Door) 54 (5–Door)
D35 B
53 (S/D) J20 57 (3–Door) U5 56 (3–Door)
51 (H/B) 59 (4–Door) 58 (4–Door)
D36
53 (S/D) 55 (5–Door) 50 (H/B)
W1 B
51 (H/B) J21 57 (3–Door) 52 (S/D)
D41
53 (S/D) 59 (4–Door) 50 (H/B)
W2 C
51 (H/B) 55 (5–Door) 52 (S/D)
D42
53 (S/D) J22 57 (3–Door) 54 (5–Door)
D77 53 (S/D) 59 (4–Door) X1 56 (3–Door)
50 (H/B) 55 (5–Door) 58 (4–Door)
J8 C
52 (S/D) J23 57 (3–Door) 54 (5–Door)
50 (H/B) 59 (4–Door) Y1 56 (3–Door)
J9 B
.ir
52 (S/D) 55 (5–Door) 58 (4–Door)
J24 A
J10 55 (5–Door) 57 (3–Door)
166
YARIS (EM01V0U)
: Relay Blocks

na
4D
4E 30
4H Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4M
31
4S

sic
62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
62 (H/B)
DQ1 Instrument Panel Wire and Instrument Panel Wire Assembly (Instrument Panel Right)
63 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
JX1 65 (3–Door) Floor Wire and Seat Airbag RH Wire (Front Seat RH)
oe
66 (4–Door)
64 (5–Door)
JY1 65 (3–Door) Floor Wire and Seat Airbag LH Wire (Front Seat LH)
66 (4–Door)
: Ground Points

62 (H/B)
D1 Left Kick Panel
63 (S/D)
62 (H/B)
63 (S/D)
lec
.ir
167
YARIS (EM01V0U)
Seat Belt Warning
(IG) (IG) (IG)

D1(A), D2(B), D76(C)
Combination Meter
7. 5A 7. 5A 10A
IGN MET GAUGE
na
Seat Belt
Driver' s
16 4E 1 4M 15 4S
LED Driver
(H/B)
Y
CPU
CAN Controller Y
B
(S/D)
CAN I/F
B
sic
1 A 21 A 20 A 24 A 9 B (H/B)
9 C (S/D)
O
W
G
(S/D)
18 7
D42
(H/B)
BR
O
Junction
Connector
22 11
W
Y(H/B)
22 11 O(H/B)
D41
oe
Junction
Connector BR
19 8
W
D16(A), J8(C), J9(B)

21 A 22 A 13 A Airbag Sensor Assembly Center
IG2 CANL CANH
E2 E1 DSP+ DSP– DBE+ DBE–

26 A 25 A 14 C 13 C 11 C 12 C
lec
W–B
W–B
Y–R
R
Y
14 4E 30 4E
2 1 4 3
17 4E LSP+ LSP– LBE+ LBE–
J10
Front Seat Inner Belt (Driver' s Side)
W–B
.ir
D1
168
YARIS (EM01V0U)
J24(A), U1(B)
na
D77 FSR+ FSR–
Hazard Warning Signal SW 8 A 4 A

IG+ PBEW P–AB PAON
GR
Y
6 8 10 9
(S/D)
(S/D)
(S/D)
GR
O
Y
(S/D)
D27
sic
Passenger' s Seat Belt/Airbag

Indicator (ON/OFF)
IG+ PBEW P–AB PAON
6 3 5 1
O
(H/B)
(H/B)
(H/B)
(H/B)
GR
O
R
Y
(S/D)
14 4S 3 4E
Y(H/B)
O(H/B) 32 4E 15 4E W
oe
BR
GR
W
G
B
17 A 23 A 12 B 13 B 16 A
P–AB PAON FSP+ FSP– SIL
D16(A), J8(C), J9(B)

lec
BR
.ir
D3
169
YARIS (EM01V0U)
Seat Belt Warning
J24(A), U1(B)
na
DIA GND BSW BGND SVC1 SIG1 SGD1 SVC3 SIG3 SGD3
2 A 3 A 9 A 5 A 11 B 7 B 1 B 5 B 9 B 3 B
W–B
GR
SB
W
G
G
R
P
Y
7 JD2
2 1 1 2 3 1 2 3
RBE+ RBE– SVC1 SIG1 SGD1 SVC3 SIG3 SGD3
G
sic Junction Connector
J11 U2 U3
D34(A), D35(B)
12 A Front Seat Inner Belt Occupant Classification Occupant Classification

Assembly (Front RH) Sensor (Front LH) Sensor (Rear LH)
20 B
O
3 4S 15 4A
31
W
4E
oe
7 4E 17 4E
W–B
L
lec
7
SIL
D15
Data Link
Connector 3
.ir
D1
170
YARIS (EM01V0U)
J24(A), U1(B)
7. 5A 7. 5A
IGN ECU–B
na
SVC2 SIG2 SGD2 SVC4 SIG4 SGD4 +B IG
12 B 8 B 2 B 6 B 10 B 4 B 1 A 7 A 2
1 4D 1
BR
W
O
R
V
V
L
L
6 JD2 1 JD2
25 AA2
1 2 3 1 2 3
SVC2 SIG2 SGD2 SVC4 SIG4 SGD4
O
L
sic
30 4B
U4 U5 8
D36
Occupant Classification Occupant Classification Junction
Sensor (Front RH) Sensor (Rear RH) Connector
11
12 4H
P
oe
lec
.ir
171
YARIS (EM01V0U)
Seat Belt Warning
: Parts Location
51 (H/B) 51 (H/B) J24 A 59 (4–Door)
D1 A D42
53 (S/D) 53 (S/D) 54 (5–Door)
na
D2 B 51 (H/B) D76 C 53 (S/D) U1 B 56 (3–Door)
51 (H/B) D77 53 (S/D) 58 (4–Door)
D15
53 (S/D) 50 (H/B) 54 (5–Door)
J8 C
51 (H/B) 52 (S/D) U2 56 (3–Door)
D16 A
53 (S/D) 50 (H/B) 58 (4–Door)
J9 B
D27 51 (H/B) 52 (S/D) 54 (5–Door)
51 (H/B) 55 (5–Door) U3 56 (3–Door)
D34 A
53 (S/D) J10 57 (3–Door) 58 (4–Door)
51 (H/B) 59 (4–Door) 54 (5–Door)
D35 B
53 (S/D) 55 (5–Door) U4 56 (3–Door)
51 (H/B) J11 57 (3–Door) 58 (4–Door)
D36
sic
53 (S/D) 59 (4–Door) 54 (5–Door)
51 (H/B) 55 (5–Door) U5 56 (3–Door)
D41 J24 A
53 (S/D) 57 (3–Door) 58 (4–Door)
: Relay Blocks

oe
4D
4E 30
4M
31
4S

62 (H/B)
63 (S/D)
lec
62 (H/B)
63 (S/D)
: Ground Points

62 (H/B)
D1 Left Kick Panel
63 (S/D)
62 (H/B)
63 (S/D)
.ir
172
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
173
YARIS (EM01V0U)
EPS
(IG) (IG)
7. 5A 10A
MET ECU–IG
na
1 4M 24 4B
B
16
A25
Junction
Connector
20
sic
D1
Combination Meter 1
B
Speedometer
P/S
11 CA2
LED Driver
oe
B
CPU
C21
CAN Controller 1 Speed Sensor
I/F I/F IG+
CAN I/F
SI SE
24 21 20 16 17 3 2
W–B
SB
W
P
lec
12 CA2 13 CA2
BR
8 4C
W–B
P
8 4D
11 AD3 6 AA2 23 AA2
G
W
.ir
W–B
D3 A1
174
YARIS (EM01V0U)
(BAT)
50A
EPS
na
2
7 4S 1
D15
Data Link
Connector 3
SIL TS
W
R
7 12
L
7 4E
sic
3 4S
LG
c1(D)
O

Junction Connector
Junction Connector
D36(A), D37(B)
D34(A), D35(B)
8 B 20 B
Power Steering Motor
1 A 13 A
M
oe P
L
b1(C)
W
R
R
B
B
6 B 1 A 2 B 11 B 1 C 2 C 6 D 5 D 7 D 8 D
IG PIG SIL TS M1 M2 TRQV TRQ1 TRQ2 TRQG
SPD CANH CANL PGND

5 B 1 B 7 B A19(A), D31(B), b1(C), c1(D) 2 A
Power Steering ECU
SB
W
R
lec
19 A 4 15
D36(A) D42
Junction Junction
Connector Connector
20 A 7 18
W–B
W
G
W
.ir
A3
175
YARIS (EM01V0U)
EPS
System Outline
∗ In order to reduce driver’s steering force, the assist current is calculated from the torque sensor signal and vehicle speed
signal of the meter or CAN communication to output to the motor.
∗ When abnormality occurs in the system, the assist is prohibited by shutting off the power source relay and motor relay in
ECU, and the warning light (P/S) in the meter is lit up.
na
: Parts Location
50 (H/B) D15 53 (S/D) 51 (H/B)
A19 A D37 B
52 (S/D) 51 (H/B) 53 (S/D)
D31 B
46 (H/B) 53 (S/D) 51 (H/B)
A25 D42
48 (S/D) 51 (H/B) 53 (S/D)
D34 A
47 (H/B) 53 (S/D) 50 (H/B)
C21 b1 C
49 (S/D) 51 (H/B) 52 (S/D)
D35 B
51 (H/B) 53 (S/D) 50 (H/B)
D1 c1 D
sic
53 (S/D) 51 (H/B) 52 (S/D)
D36 A
D15 51 (H/B) 53 (S/D)
: Relay Blocks

4C
oe
4D 30
4M
31
4S

62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
lec
60 (H/B)
61 (S/D)
: Ground Points

60 (H/B)
61 (S/D)
62 (H/B)
A3 Left Cowl Top Side Panel
63 (S/D)
62 (H/B)
63 (S/D)
.ir
176
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
177
YARIS (EM01V0U)
Power Window
(BAT) (BAT) (IG)
A28
120A ALT
7. 5A Fusible 10A
ECU–B Link Block ECU–IG
na
2
1
1
B
1 4G
L
PWR
Relay
sic
25 AA2 1
13 5
20A 20A PWS IG
30A
RL RR POWER
DOOR DOOR Main Body ECU
BECU DCTY
2
L
6 26
17 4E 1 4A 19 4A 2 4H 11 4H 30 4B 21 4A
oe
W–B
GR
SB
SB
R
L
GR
SB
SB
L
Door Courtesy SW
lec
1
(Front LH)
J2
.ir
W–B
D1
178
YARIS (EM01V0U)
∗ 1 : w/ Rear Power Window
∗ 2 : w/o Rear Power Window
G1(A), (B)
Power Window Master SW
na
B U D D U
6 A 16 A 15 A 4 A 3 A (∗1)
15 B 16 B 18 B 12 B 10 B (∗2)
GR
P
2 GD2 11 GD2 10 GD2
R
1 2
M
G4
GR
P
Power Window Regulator Motor
sic
(Front LH)
11 FD2 10 FD2
oe W
GR
SB SB
SB SB
L
L
lec
2 FD2 5 2
L 3
F1
Power Window SW (Front RH)
Down
Up
4 1
G
R
2 1
M
F4
.ir
Power Window Regulator Motor (Front RH)
179
YARIS (EM01V0U)
Power Window
G1(A), (B)
na
U D U D E
12 A 13 A 10 A 18 A 1 A (∗1)
7 B (∗2)
G
R
Y
B
8 GD2 9 GD2 17 GD2 18 GD2
G
R
Y
B
sic
11 JD1 10 JD1 2 JD1 1 JD1
G
R
Y
2 IJ1 3 IJ1 2 HJ1 3 HJ1

oe
W–B
G
G
R
SB
SB
SB
SB
lec
Power Window SW (Rear RH)
Power Window SW (Rear LH)
1 IJ1 5 1 1 HJ1 5 1
SB 3 SB 3
Down
Down
Up
Up
H1
I1
4 2 4 2
Y
1 2 1 2
M M
I2 H2
.ir
Power Window Regulator Power Window Regulator
Motor (Rear LH) Motor (Rear RH)
3 5B
D1
180
YARIS (EM01V0U)
System Outline
1. Manual Up–and–Down Function
During IG ON, one step operation upward (Pull) or downward (Push) of the door switch makes the door glass move upward
or downward. Manual operation of the power window master switch for each window can control operation of each window
remotely from the driver’s seat. The door glass stops at the position when the switch is released.
na
2. One–Touch Auto Down Function
During IG ON, two step operation downward (Push) of the master switch of the driver’s door glass makes the driver’s door
glass move automatically downward to the full–open position. The auto operation to either direction can be suspended by
one step operation to the opposite side from the operating direction.
3. Power Window Jam Protection Function
If a foreign object gets jammed in the window during the manual operation, the door glass automatically goes down by about
50mm (or for about one second). If the door glass opening is less than 200mm after the move, the glass goes down to reach
about 200mm of the opening (or for about 5 seconds).
4. Window Lock
All the power window operations except driver’s side are disabled when the window lock switch of the power window master
switch is pressed on.
sic
5. Fail Mode LED Blinking
Self–diagnosis switches it to the fail mode and the indicator light (LED) in the switch knob blinks to inform the user under the
following conditions.
∗ When abnormality is found in the hall IC that detects the position, speed and direction of the door glass.
∗ When there is larger difference than the predetermined one between the position information that the hall IC detects and
the position information that the power window switch memorizes.
: Parts Location
43, 46 (H/B) A 58 (4–Door) H2 58 (4–Door)
A28
43, 48 (S/D) 54 (5–Door) 54 (5–Door)
G1 I1
oe
54 (5–Door) B 56 (3–Door) 58 (4–Door)
F1 56 (3–Door) 58 (4–Door) 54 (5–Door)
I2
58 (4–Door) 54 (5–Door) 58 (4–Door)
54 (5–Door) G4 56 (3–Door) 55 (5–Door)
F4 56 (3–Door) 58 (4–Door) J2 57 (3–Door)
58 (4–Door) 54 (5–Door) 59 (4–Door)
H1
54 (5–Door) 58 (4–Door)
G1 A
56 (3–Door) H2 54 (5–Door)
: Relay Blocks

lec
4H 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
5B 38 Front Door LH Wire and J/B No.5 (Left Kick Panel)
.ir
181
YARIS (EM01V0U)
Power Window
62 (H/B)
63 (S/D)
na
62 (H/B)
FD2 Front Door RH Wire and Instrument Panel Wire (Right Kick Panel)
63 (S/D)
62 (H/B)
GD2 Front Door LH Wire and Instrument Panel Wire (Left Kick Panel)
63 (S/D)
64 (5–Door)
HJ1 Rear Door No.1 Wire and Floor Wire (Right Center Pillar)
66 (4–Door)
64 (5–Door)
IJ1 Rear Door No.2 Wire and Floor Wire (Left Center Pillar)
66 (4–Door)
62 (H/B)
63 (S/D)
sic
: Ground Points

62 (H/B)
D1 Left Kick Panel
63 (S/D)
oe
lec
.ir
182
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
183
YARIS (EM01V0U)
Door Lock Control
D33(A)
(BAT) (BAT) (IG) (ACC) Main Body ECU
7. 5A 25A 10A 7. 5A
ECU–B D/L ECU–IG ACC
na
ACC IG ALTB BECU KSW
2 21 5 4 6 9
30 4B 7 4D
sic
25
L L
AA2
Unlock Warning SW
1
D19
2
oe
W–B
lec
.ir
1 5A
D1
184
YARIS (EM01V0U)
D33(A)
Main Body ECU
na
DCTY GND1 LSWP UL2 L2 ACT– ACT+
26 1 5 A 16 14 3 2
21 4A 17 4E 1 4S 15 4H 16 4H 18 4H 8 4H
sic W–B
W–B
(S/D)
O
R
P
L
17 JD1 9 FD1 8 FD1 7 FD1 20 FD1 10 FD1
BR
G
O
P
L
7 5 6 1 4
LSSR UL L UL L
J2
Detection
oe
Unlock
Lock
Unlock
E
8 F5
Door Lock Assembly
(Front Passenger' s Side)
W–B
lec
W–B
(S/D)
W–B
(S/D)
W–B
(H/B)
.ir
1 6B 6 6B 3 6A
D1 D2
185
YARIS (EM01V0U)
Door Lock Control
D33(A)
Main Body ECU
na
LSWD UL3 ACTD
21 A 14 A 2 A
N3
Back Door
Lock Assembly
SB
M
Y
L
1 2
(H/B)
(H/B)
GR
P
7 4H 17 4H 3 4A 4 4A
7 MN1 6 MN1
sic
(H/B)
(H/B)
B
B
8 MJ1 9 MJ1
BR
SB
W
Y
L
GR
(H/B)
(H/B)
P
GR
P
J28(A), J29(B)
9 GD1 8 GD1 7 GD1 20 GD1 10 GD1 8 B 2 B Junction Connector 7 B 1 B
BR
G
O
P
L
8 10 9 1 4
LSSR UL L UL L 11 A 5 A 12 A 6 A
GR
GR
P
P
Detection
oe
Unlock
Lock
Unlock
M
8 HJ1 9 HJ1 8 IJ1 9 IJ1
GR
GR
P
P
E 4 1 4 1
7 G5 L UL Unlock Unlock L UL
Door Lock Assembly (Driver' s Side) Detection Detection
M M
E LSSR E LSSR
H3 9 6 9 6 I3
Door Lock Door Lock
(S/D)
(S/D)
(S/D)
(S/D)
W–B
W–B
Assembly Assembly
O
(Rear RH) (Rear LH)
12 HJ1 13 HJ1 12 IJ1 13 IJ1

W–B
lec (S/D)
(S/D)
(S/D)
(S/D)
W–B
W–B
O
W–B
(S/D)
O(S/D)
W–B W–B
(S/D) (S/D)
W–B W–B
(H/B) (H/B)
W–B
.ir
186
YARIS (EM01V0U)
D33(A)
Main Body ECU
na
LSR L1 UL1
24 A 12 10
∗ 3 : w/ Power Window
∗ 4 : S/D w/o Power Window
(S/D)
O
10 4C 11 4E 4 4H 5 4H
8 JD2
O(S/D)
sic
LG
O
(S/D)
O
BR(S/D)
5 GD1 6 GD1
6 FD1 5 FD1
(S/D)
(S/D)
(H/B)
(H/B)
(∗3)
(∗3)
(∗4)
(∗4)
BR
BR
BR
BR
O
O
2 A 9 A (∗1)

2 3 4 5 1 B 9 B (∗2) 3 2
L UL L UL
(Driver' s Side)
Unlock
Unlock
Unlock
Lock
Lock
Lock
oe D30
G7
F7
Unlock
Lock
4 6 4
G1(A), (B)
E
(S/D)
(H/B)
W–B
W–B
1 A (∗1)
7 B (∗2)
W–B
W–B
(∗3)
(∗4)
13
D40
Junction
Connector
11
lec (H/B)
W–B
O(S/D)
W–B
(S/D)
W–B
(H/B)
W–B
.ir
1 5B 3 5B 4 5B
D1
187
YARIS (EM01V0U)
Door Lock Control
D33(A)
Main Body ECU
na
CANL CANH
22 A 23 A
W
R
16 5
D42
Junction
Connector
22 11
sic
W
22 11
D41
Junction
Connector
19 8
W
22 A 13 A
CANL CANH D16(A), J8(C)
oe
Airbag Sensor
Assembly Center
DSP+ DSP– DBE+ DBE–
14 C 13 C 11 C 12 C
Y–R
R
Y
2 1 4 3
LSP+ LSP– LBE+ LBE– J10
Front Seat Inner Belt
(Driver' s Side)
lec
.ir
188
YARIS (EM01V0U)
System Outline
1. Manual Lock & Unlock Function
All the doors (Including the back door) are locked or unlocked by operating the door lock control switch (For manual
operation) to ’lock’ or ’unlock’ side.
2. Door Key–Linked Lock & Unlock Function
na
All the doors (Including the back door) are locked or unlocked by operating the key plate to ’lock’ or ’unlock’ side after
inserting the key plate into driver’s door key cylinder.
3. Key Confinement Prevention Function
To prevent the key confinement in the cabin, it controls not to lock the doors with the door lock control switch (For manual
operation or for key–linked) or the door lock knob when the key plate is inserted in the ignition key cylinder with the driver’s
door open.
: Parts Location
51 (H/B) F7 58 (4–Door) 50 (H/B)
sic
D16 A J8 C
53 (S/D) 54 (5–Door) 52 (S/D)
A
51 (H/B) G1 58 (4–Door) 55 (5–Door)
D19
53 (S/D) B 56 (3–Door) J10 57 (3–Door)
D30 51 (H/B) 54 (5–Door) 59 (4–Door)
51 (H/B) G5 56 (3–Door) 55 (5–Door)
D33 A
53 (S/D) 58 (4–Door) J28 A 57 (3–Door)
D40 51 (H/B) G7 58 (4–Door) 59 (4–Door)
51 (H/B) 54 (5–Door) 55 (5–Door)
D41 H3
53 (S/D) 58 (4–Door) J29 B 57 (3–Door)
51 (H/B) 54 (5–Door) 59 (4–Door)
D42 I3
53 (S/D) 58 (4–Door) 54 (5–Door)
N3
54 (5–Door) 55 (5–Door) 56 (3–Door)
oe
F5 56 (3–Door) J2 57 (3–Door)
58 (4–Door) 59 (4–Door)
: Relay Blocks

lec
4C
4D
30
4H
4S 31
6B 40 Front Door RH Wire and J/B No.6 (Right Kick Panel)
.ir
189
YARIS (EM01V0U)
Door Lock Control
62 (H/B)
63 (S/D)
na
62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
66 (4–Door)
64 (5–Door)
66 (4–Door)
JD1
JD2
64 (5–Door)
sic
65 (3–Door)
64 (5–Door)
65 (3–Door)
: Ground Points

62 (H/B)
D1 Left Kick Panel
63 (S/D)
62 (H/B)
D2 Right Kick Panel
63 (S/D)
oe
lec
.ir
190
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
191
YARIS (EM01V0U)
Wireless Door Lock Control
D33(A)
7. 5A 25A 10A 7. 5A
BCTY(H/B)
na
ACC IG ALTB BECU KSW LGCY(S/D)
2 21 5 4 6 9 23
30 4B 7 4D 7 4A
sic
25
L L
AA2
(H/B)
SB
Y
Junction Connector
Unlock Warning SW
1
6 B
J29(B)
D19
5 B
2
oe
(H/B)
BR
12 MJ1
(H/B)
BR
15 MN1
(H/B)
W–B
BR
lec
Back Door Courtesy SW
2
Courtesy
N2
1
.ir
(H/B)
W–B
1 5A
D1 N1
192
YARIS (EM01V0U)
D33(A)
Main Body ECU
na
DCTY PCTY RRCY LSWP ACT– ACT+
26 20 22 5 A 3 2
21 4A 24 4A 20 4A 5 4A 18 4H 8 4H
sic (∗2)
(∗2)
G
O
R
P
L
L
Door Courtesy SW (Front RH)
9 FD1 20 FD1 10 FD1
1 1 1 1
O
P
L
7 1 4
J32
J33
LSSR UL L
J2
J1
Detection
oe
Unlock
M
(∗1)
(∗1)
G
L
3 JD2 2 JD2 E
8 F5
Door Lock Assembly
(∗1)
(∗1)
G
L
21 20
Combination
W–B
Meter
lec
D76
22
(∗1)
(∗1)
Y
5 JD2
∗ 1 : S/D ∗3
w/ ABS,
.ir
1 6B
w/ Air Conditioning
D2
193
YARIS (EM01V0U)
D33(A)
Main Body ECU
na
LSWD ACTD
21 A 2 A
N3
Back Door
Lock Assembly
SB
M
L
1 2
(H/B)
(H/B)
GR
P
17 4H 3 4A 4 4A
7 MN1 6 MN1
sic
(H/B)
(H/B)
B
B
8 MJ1 9 MJ1
SB
W
L
GR
(H/B)
(H/B)
P
GR
P
J28(A), J29(B)
9 GD1 20 GD1 10 GD1 8 B 2 B Junction Connector 7 B 1 B
O
P
L
8 1 4
LSSR UL L 11 A 5 A 12 A 6 A
GR
GR
P
P
Detection
oe
Unlock
M
8 HJ1 9 HJ1 8 IJ1 9 IJ1
GR
GR
P
P
E 4 1 4 1
7 G5 L UL Unlock Unlock L UL
Door Lock Assembly Detection Detection
(Driver' s Side)
M M
E LSSR E LSSR
H3 9 6 9 6 I3
Door Lock Door Lock
(S/D)
(S/D)
(S/D)
(S/D)
W–B
W–B
Assembly Assembly
O
(Rear RH) (Rear LH)
12 HJ1 13 HJ1 12 IJ1 13 IJ1

lec (S/D)
(S/D)
(S/D)
(S/D)
W–B
W–B
W–B
O
O(S/D)
W–B(S/D)
.ir
1 5B
D1
194
YARIS (EM01V0U)
∗ 4 : w/ Theft Deterrent System
D33(A)
Main Body ECU
na
LSR SRX STX HAZ GND1 ILE
24 A 18 A 19 A 25 1 7
8
(S/D)
(∗4)
(∗4)
O
O
P
EHW
FLASH Relay
1 4S 17 4E 1 4K 2 4K
8 JD2
sic
(S/D)
(S/D)
W–B
W–B
W–B
O
P
L
oe
17 JD1
24 25
BRK+ BRK– 1
Room Lamp (Center)
Door
Off
On
lec
D26
K2
Theft Warning ECU 3 2

(S/D)
W–B
W–B
O(S/D)
W–B(S/D)
W–B
.ir
D1
195
YARIS (EM01V0U)
D33(A)
Main Body ECU (BAT)
15A
DOME
na
PRG RDA
17 A 16 A 2
1
W
L
13 4B
5 4K 4 4P
sic
L
Junction Connector
D38(A), D39(B)
L 1 B
8 A
L
oe
16 JD1 15 JD1 14 JD1
W
3 2 5
PRG RDA +B
lec
GND
J13 1
W–B
W–B
(H/B)
7 MJ1
(H/B)
B
8 MN1
W–B
.ir
(H/B)
W–B
N1 J2
196
YARIS (EM01V0U)
System Outline
1. Wireless Lock & Unlock Function
Pushing the lock button locks all the doors and pushing the unlock button unlocks the all the doors.
2. 30–Second Auto Lock Function
If none of the door are opened within 30 seconds after they are unlocked with the unlock button, all the doors are locked
na
automatically again to prevent the doors from being left open.
3. Operation Prohibition Function with the Door Open
When one of the doors is ajar or open, the door lock operation through the wireless remote control is prohibited.
4. Repeat Function
If a door lock operation has not been confirmed for some reason after the system conducts the lock operation, the system
repeats the lock operation after approximately one second.
5. Answer Back Function (Hazard Light Flashing)
The hazard light flashes once when locking, and flashes twice when unlocking if the doors are locked/unlocked through the
wireless remote control.
6. Key Reminder Function
sic
When the key is inserted in the key cylinder, all the operations of the wireless remote control system are prohibited.
7. Illuminating Function
When the doors are unlocked with the wireless remote control, the interior lights are lit for approximately 15 seconds if the
interior light switch is at ’door’ position.
8. Wireless Security Function
The security function is adopted under which the door unlock and the like are controlled only when the wireless receiver
checks the encrypted code sent from the transmitter key and identifies it as its own vehicle’s code.
: Parts Location
51 (H/B) 56 (3–Door) 57 (3–Door)
oe
D19 G5 J28 A
53 (S/D) 58 (4–Door) 59 (4–Door)
51 (H/B) 54 (5–Door) 55 (5–Door)
D26 H3
53 (S/D) 58 (4–Door) J29 B 57 (3–Door)
51 (H/B) 54 (5–Door) 59 (4–Door)
D33 A I3
53 (S/D) 58 (4–Door) 55 (5–Door)
J32
51 (H/B) 55 (5–Door) 59 (4–Door)
D38 A
53 (S/D) J1 57 (3–Door) 55 (5–Door)
J33
51 (H/B) 59 (4–Door) 59 (4–Door)
D39 B
53 (S/D) 55 (5–Door) 54 (5–Door)
D76 53 (S/D) J2 57 (3–Door) K2 56 (3–Door)
lec
54 (5–Door) 59 (4–Door) 58 (4–Door)
F5 56 (3–Door) 55 (5–Door) 54 (5–Door)
N2
58 (4–Door) J13 57 (3–Door) 56 (3–Door)
G1 A 54 (5–Door) 59 (4–Door) 54 (5–Door)
N3
G5 54 (5–Door) J28 A 55 (5–Door) 56 (3–Door)
: Relay Blocks

.ir
197
YARIS (EM01V0U)
na
4D
4H
4P
4S

sic
62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
66 (4–Door)
64 (5–Door)
66 (4–Door)
62 (H/B)
oe
JD1
JD2 63 (S/D)
64 (5–Door)
65 (3–Door)
64 (5–Door)
65 (3–Door)
: Ground Points

62 (H/B)
lec
D1 Left Kick Panel
63 (S/D)
62 (H/B)
D2 Right Kick Panel
63 (S/D)
64 (5–Door)
J2 65 (3–Door)
64 (5–Door)
65 (3–Door)
.ir
198
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
199
YARIS (EM01V0U)
Theft Deterrent
D33(A)
7. 5A 25A 10A 7. 5A
BCTY(H/B)
na
ACC IG ALTB BECU LGCY(S/D)
2 21 5 4 6 23
30 4B 7 4A
sic
25
L L
AA2
SB
Junction Connector
6 B
J29(B)
5 B
oe
(H/B)
BR
12 MJ1
(H/B)
BR
15 MN1
(S/D)
(H/B)
BR
BR
lec
Back Door Courtesy SW
3 2
Door Lock Assembly
Courtesy
Courtesy
(Luggage)
J42
N2
2 1
.ir (S/D)
(H/B)
W–B
W–B
J2 N1
200
YARIS (EM01V0U)
D33(A)
Main Body ECU
na
DCTY PCTY RRCY HAZ GND1 LSWP UL2 L2 ACT– ACT+
26 20 22 25 1 5 A 16 14 3 2
8
EHW
FLASH Relay
21 4A 24 4A 20 4A 5 4A 17 4E 1 4S 15 4H 16 4H 18 4H 8 4H
sic
(S/D)
W–B
W–B
(∗2)
(∗2)
G
O
R
P
L
L
17 JD1 9 FD1 8 FD1 7 FD1 20 FD1 10 FD1

1 1 1 1
J32
J33
BR
J2
J1
O
P
L
oe
(∗1)
(∗1)
(∗1)
G
Y
L
7 5 6 1 4
3 JD2 2 JD2 LSSR UL L UL L
Detection
Unlock
Lock
Unlock
(∗1)
(∗1)
M
G
L
21 20
E
Combination
8 F5
Door Lock Assembly
Meter
lec
D76
22
W–B
(∗1)
Y
5 JD2 W–B
(S/D)
W–B
∗ 1 : S/D ∗3
∗ 2 : H/B, S/D Except ∗3 (H/B)
∗ 3 : Cold Area Spec. , W–B
w/ ABS, (S/D)
.ir
1 6B 3 6A 6 6B
w/ Air Conditioning
D1 D2
201
YARIS (EM01V0U)
Theft Deterrent
D33(A)
Main Body ECU
na
LSWD UL3 ACTD LSR
21 A 14 A 2 A 24 A
(S/D)
SB
O
Y
L
7 4H 17 4H 3 4A 4 4A
8 JD2
sic
(S/D)
O
GR
BR
SB
W
Y
P
L
J28(A), J29(B)
8 B 2 B Junction Connector
9 GD1 8 GD1 7 GD1 20 GD1 10 GD1
11 A 5 A 12 A 6 A
BR
G
O
P
L
GR
GR
P
P
oe
8 HJ1 9 HJ1 8 IJ1 9 IJ1
8 10 9 1 4
LSSR UL L UL L
GR
GR
P
P
Detection
Unlock
4 1 4 1
Lock
Unlock
M
L UL Unlock Unlock L UL
Detection Detection
M M
E E LSSR E LSSR
7 G5 H3 9 6 9 6 I3
Door Lock Assembly (Driver' s Side) Door Lock Door Lock
lec (S/D)
(S/D)
(S/D)
(S/D)
W–B
W–B
Assembly Assembly
O
(Rear RH) (Rear LH)
12 HJ1 13 HJ1 12 IJ1 13 IJ1

W–B
(S/D)
(S/D)
(S/D)
(S/D)
W–B
W–B
O
W–B
(S/D)
W–B W–B
(H/B) (H/B)
W–B W–B
(S/D) (S/D)
W–B
.ir
202
YARIS (EM01V0U)
D33(A)
Main Body ECU
na
HRLY L1 UL1
3 A 12 10
(BAT)
H–LP LO LH
H–LP LH/
10A
10 4C 11 4E 4 4H 5 4H
LG
O
O(S/D)
sic
BR(S/D)
5 GD1 6 GD1
GR
LG
6 FD1 5 FD1
(H/B)
(H/B)
(S/D)
(S/D)
(∗7)
(∗7)
(∗4)
(∗4)
BR
BR
BR
BR
G
O
2 A 9 A (∗5)

2 4 5 2 3 1 B 9 B (∗6) 3 2
L UL L UL
(Driver' s Side)
H–LP/AMT Relay
Unlock
Unlock
Unlock
Lock
Lock
Lock
D30
oe
E
G7
F7
Unlock
Lock
6 4 4
G1(A), (B)
2 E
(H/B)
(S/D)
W–B
W–B
1 A (∗5)
7 B (∗6)
V
W–B
W–B
(∗7)
(∗4)
17 4B
lec
3 4J
Y
6 13
D40
Junction
Connector
8 11
(H/B)
W–B
W–B
(H/B)
W–B
(S/D)
W–B
.ir
1 5B 3 5B 4 5B
∗ 7 : w/ Power Window
D1
203
YARIS (EM01V0U)
Theft Deterrent
D33(A)
Main Body ECU
na
HORN KSW SRX STX PRG RDA
15 9 18 A 19 A 17 A 16 A
(BAT)
W
O
R
P
10A
HORN
28 4B 7 4D 6 4E
sic
LG
HORN
Y
Y
Relay
7 1A
Unlock Warning SW
16 JD1 15 JD1
D19
R
2
oe
3 2
PRG RDA
J13
O
W–B
lec
P
Y
.ir
1 5A
D1
204
YARIS (EM01V0U)
(BAT) (BAT) (IG)
15A 7. 5A 10A
DOME ECU–B ECU–IG
na
W–B W–B
2 2
W–B
1 1 7 4S
L
1 A (S/D)
L
25 AA2 2 B (H/B) 2
Security Horn
Courtesy SW
Engine Hood
L
A18(A), (B)
R
L
A23
12 MN1
13 4B 30 4B 2 A (S/D) 1
(H/B)
1 B (H/B)
P
sic
15 MJ1
5 4P 12 4H
W
(S/D)
(H/B)
(H/B)
(S/D)
P
P
Connector
11 A 8 B
D36(A), D37(B)
Junction
D37(B)
16 AD5 15 AD5 11 JD2 16 JD2

B
Connector
Junction
9 B
(S/D)
(H/B)
O
P
3 B 2 B
(S/D)
(H/B)
GR
BR
O
L
oe
11 13 9 4 15 6
+B1 +B2 IG DSWH SH– LSR(H/B)
LUG(S/D)
BRK– BRK+ KSW E IND

25 24 7 16 29 D26
G Theft Warning ECU
(S/D)
18
(H/B)
W–B
LG
O
D35
Junction
Connector
16
O LG
(S/D)
Back Door Position SW
2 2 2
lec
Door Lock Assembly
P
Detection
Detection
Unlock
Unlock
(Luggage)
D25
Security Indicator Lamp
Y
J43
N4
1 1
6
W–B
5
10 D40
(H/B)
(S/D)
W–B
W–B
W–B
Junction
Connector
11
.ir
W–B
3 6A
D2 N1 J2 A1
205
YARIS (EM01V0U)
Theft Deterrent
: Parts Location
A 48 (S/D) 54 (5–Door) 55 (5–Door)
A18
B 46 (H/B) F5 56 (3–Door) J13 57 (3–Door)
na
46 (H/B) 58 (4–Door) 59 (4–Door)
A23
48 (S/D) F7 58 (4–Door) 55 (5–Door)
51 (H/B) 54 (5–Door) J28 A 57 (3–Door)
D19 A
53 (S/D) G1 58 (4–Door) 59 (4–Door)
51 (H/B) B 56 (3–Door) 55 (5–Door)
D25
53 (S/D) 54 (5–Door) J29 B 57 (3–Door)
51 (H/B) G5 56 (3–Door) 59 (4–Door)
D26
53 (S/D) 58 (4–Door) 55 (5–Door)
J32
D30 51 (H/B) G7 58 (4–Door) 59 (4–Door)
51 (H/B) 54 (5–Door) 55 (5–Door)
D33 A H3 J33
53 (S/D) 58 (4–Door) 59 (4–Door)
sic
D35 53 (S/D) 54 (5–Door) J42 59 (4–Door)
I3
51 (H/B) 58 (4–Door) J43 59 (4–Door)
D36 A
53 (S/D) 55 (5–Door) 54 (5–Door)
N2
51 (H/B) J1 57 (3–Door) 56 (3–Door)
D37 B
53 (S/D) 59 (4–Door) 54 (5–Door)
N4
51 (H/B) 55 (5–Door) 56 (3–Door)
D40
53 (S/D) J2 57 (3–Door)
D76 53 (S/D) 59 (4–Door)
: Relay Blocks

oe
4C
4D
4E 30
lec
4J
4P
31
4S
.ir
206
YARIS (EM01V0U)
62 (H/B)
63 (S/D)
na
62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
66 (4–Door)
64 (5–Door)
66 (4–Door)
62 (H/B)
JD1
sic
63 (S/D)
Floor Wire and Instrument Panel Wire (Instrument Panel Left)
62 (H/B)
JD2
63 (S/D)
64 (5–Door)
65 (3–Door)
64 (5–Door)
65 (3–Door)
: Ground Points

60 (H/B)
61 (S/D)
oe
62 (H/B)
D1 Left Kick Panel
63 (S/D)
62 (H/B)
D2 Right Kick Panel
63 (S/D)
J2 66 (4–Door) Lower Back Panel Left
64 (5–Door)
65 (3–Door)
lec
.ir
207
YARIS (EM01V0U)
Front Wiper and Washer
(IG)
15A
WSH
na
2 4B
L(H/B)
W
2
Junction Connector
Y
3
A26
L(H/B)
sic
L(S/D)
5 AD2
Y
L
D5(A), D6(B)
1
Washer Motor
Windshield Wiper SW Assembly 3 B 4 B

Windshield
M +1 +2
A5
2 +B INT1 INT2 +S +1 +2 B1
MIST Washer SW
G
Wiper SW
OFF WF EW
INT Off
oe
LO On
1 AD2
HI
G
+S INT1 INT2 B1
lec
+B +S W E
Wiper Relay
+S +B WF EW
1 B 2 B 3 A 2 A
W
W–B
G
B
.ir
W–B
208
YARIS (EM01V0U)
(IG)
20A
WIP
na
1 4H 36 4B
B
L
sic
2 AD2
4 4E
25 4B
W
Y
3 5 1 2
+2 +1 +S B
oe
M
E
lec
4 A9
Windshield Wiper Motor
W–B
2 4E
W–B
.ir
W–B 17 4E
W–B
D1 A1
209
YARIS (EM01V0U)
Front Wiper and Washer
System Outline
1. Intermittent Function
When the wiper control switch is turned to INT position, the wiper makes intermittent operation with an interval time of
approximately 3.3 seconds.
2. Washer–Linked Function
na
When the washer switch is turned ON for approximately 0.3 seconds or more, the wiper starts a LO operation at the same
time as the washer fluid is ejected. When the switch is turned ON for approximately 1.5 seconds or more, the wiper keeps a
LO operation for approximately 2.2 seconds after the washer switch is turned OFF, and then stops its operation.
: Parts Location
46 (H/B) A9 48 (S/D) D5 A 53 (S/D)
A5
48 (S/D) A26 50 (H/B) 51 (H/B)
D6 B
A9 46 (H/B) D5 A 51 (H/B) 53 (S/D)
sic
4E
4H

62 (H/B)
63 (S/D)
: Ground Points
oe
60 (H/B)
61 (S/D)
62 (H/B)
D1 Left Kick Panel
63 (S/D)
lec
.ir
210
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
211
YARIS (EM01V0U)
Rear Wiper and Washer
(IG) (IG)
D5(A), D6(B)
Windshield Wiper SW Assembly
15A 15A
RR WIP WSH WR +1R EW
na
Rear Wiper and

Wash
Washer SW
Off
25 4A 2 4B
On
On+Washer
W
L
5 B 7 A 2 A
2
A26
4 MJ1 Junction Connector
W–B
O
L
1
18 JD1
sic
L
L
A4
W
M Rear Washer Motor
6 MJ1
2
L
L
2 MN1 10 AD2 9 MN1
oe
L
W
1 2
N1
B L Rear Wiper Motor Assembly
M
lec
2 4E
17 4E
.ir W–B
D1
212
YARIS (EM01V0U)
: Parts Location
A4 46 (H/B) D5 A 51 (H/B) 54 (5–Door)
N1
A26 50 (H/B) D6 B 51 (H/B) 56 (3–Door)
na

AD2 62 (H/B) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
JD1 62 (H/B) Floor Wire and Instrument Panel Wire (Instrument Panel Left)
sic
64 (5–Door)
65 (3–Door)
64 (5–Door)
65 (3–Door)
: Ground Points

D1 62 (H/B) Left Kick Panel
oe
lec
.ir
213
YARIS (EM01V0U)
Shift Lock
(ACC) (BAT) (IG)
7. 5A ACC2 10A 10A

STOP GAUGE
Fuse Block
na D43
18 4B 2 4P
B
B
2
Stop Lamp SW
A13
1
sic G
12 4B
18 4S
G
oe
D22
6 7 1 Shift Lock Control ECU
ACC STP IG
SLS+ SLS– KLS+ E

12 8
Shift Lock Solenoid
lec L
W–B
1
Key Interlock
Solenoid
D13
12
W–B 5 D40
Junction
Connector
11
W–B
.ir
3 6A
D2
214
YARIS (EM01V0U)
System Outline
The shift lever can be shifted from P range only when the brake pedal is depressed with the ignition key at ON position.
: Parts Location
na
50 (H/B) 51 (H/B) 45, 51 (H/B)
A13 D22 D43
52 (S/D) 53 (S/D) 45, 53 (S/D)
51 (H/B) 51 (H/B)
D13 D40
53 (S/D) 53 (S/D)
4P
sic
4S
: Ground Points

62 (H/B)
D2 Right Kick Panel
63 (S/D)
oe
lec
.ir
215
YARIS (EM01V0U)
Rear Window Defogger
(BAT) (IG) (IG)
10A GAUGE
30A 7. 5A
DEF A/C
na
2
DEF
Relay
2 4F 12 4Q 10 4S
O
B
B
sic
15 DE1 12 DE1
20 JD2
O
15
(H/B)
E10
B
Junction
Connector
(S/D)
17
B
P
E6
(H/B)
(H/B)
B
Rear Window Defogger SW 2 3

RDEF IG+
oe
1 1
J31
Noise Filter J45
Noise
Filter
1 MJ1
2
Rr E
DEF
(H/B)
(S/D)
B
Rear
Window Off
Defogger SW
On
E
lec
1
1 A (H/B)
1 D (S/D)
J44(D), M2(A), O1(B), (C)
W–B
W–B
Rear Window
Defogger
1 B (H/B)
1 C (S/D) 5 7
D40
Junction 9 DE1 E10
Connector Junction
Connector
11 5
W–B
W–B
.ir
B
3 6A
O1 D2
216
YARIS (EM01V0U)
: Parts Location
51 (H/B) E10 52 (S/D) 54 (5–Door)
D40 M2 A
53 (S/D) 55 (5–Door) 56 (3–Door)
J31
na
50 (H/B) 57 (3–Door) 54 (5–Door)
E6 B
52 (S/D) J44 D 59 (4–Door) O1 56 (3–Door)
E10 50 (H/B) J45 59 (4–Door) C 58 (4–Door)
4F 30
4Q Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
31
4S
sic
62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
65 (3–Door)
: Ground Points

oe
62 (H/B)
D2 Right Kick Panel
63 (S/D)
64 (5–Door)
Back Door Panel Left
O1 65 (3–Door)
66 (4–Door) Right Rear Quarter Panel
lec
.ir
217
YARIS (EM01V0U)
Remote Control Mirror
(ACC)
7. 5A
ACC
na
6 4S
GR
13 B
D34(A), D35(B)
Junction Connector
19 A
GR
sic
D12
8 Outer Mirror SW
B
7 E
Operation SW
Right/
Down
Down
Right
Left/
Left
Up
Up
MH MV
Select SW
Left Right Left Right
HL HR VL VR M+
5 2 4 3 6
oe SB
SB
O
P
14
12
13 D38
Junction
Connector
SB
SB
13 GD1 12 GD1 12 FD1 13 FD1 14 FD1 G

14 GD1
lec
W–B
SB
SB
W
B
3 5 3 5
MH MV MH MV
Outer Rear View Mirror
Outer Rear View Mirror
M M M M
(RH)
(LH)
M+ M+
G2
F2
4 4
W
.ir
4 5A
D1
218
YARIS (EM01V0U)
: Parts Location
51 (H/B) D35 B 53 (S/D) F2 58 (4–Door)
D12
53 (S/D) 51 (H/B) 54 (5–Door)
D38
na
51 (H/B) 53 (S/D) G2 56 (3–Door)
D34 A
53 (S/D) 54 (5–Door) 58 (4–Door)
F2
D35 B 51 (H/B) 56 (3–Door)
4S 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)

sic
62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
: Ground Points

62 (H/B)
D1 Left Kick Panel
63 (S/D)
oe
lec
.ir
219
YARIS (EM01V0U)
Cigarette Lighter / Power Outlet
(ACC)
15A
CIG
na
3 4Q
GR
1
D14
ACC Cigarette Lighter or Power Outlet
sic
E
2
(H/B)
W–B
(S/D)
W–B
oe
5
D40
Junction Connector
11
lec W–B
(S/D)
W–B
(H/B)
.ir
6 6A 3 6A
D2
220
YARIS (EM01V0U)
: Parts Location
D14 51 (H/B) D14 53 (S/D) D40 51 (H/B)

na
4Q 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
: Ground Points

62 (H/B)
D2 Right Kick Panel
63 (S/D)
sic
oe
lec
.ir
221
YARIS (EM01V0U)
Audio System
(IG) (IG)
7. 5A 10A
MET ECU–IG
na
1 4M
24 4B
(S/D)
B
(S/D)
B
16
Connector
Junction
A25
20
(S/D)
sic
B
1 11 CA2
(S/D)
B
5V IC
Speed Sensor
IG+
Combination Meter
CPU
oe
C21
SI SE
3 2
I/F I/F
D1
(S/D)
(S/D)
W–B
P
16 17 24
12 CA2 13 CA2
(S/D)
(S/D)
(S/D)
BR
SB
(S/D)
(S/D)
W–B
P
lec
6 AA2 23 AA2
(S/D)
(S/D)
W–B
P
11 AD3
SB
(S/D)
.ir
D3 A1
222
YARIS (EM01V0U)
(ACC) (BAT)
7. 5A 15A
ACC DOME
na
2
14 4D 1
GR
L
sic
8 AD2 D32
Antenna Amplifier
B
1
B
L
D10(A), D11(B), D74(C)

3 A 4 A 8 A Radio Receiver Assembly
ACC B ANT
oe
SPD FR– FR+ FL– FL+ GND
3 C 5 A 1 A 6 A 2 A 7 A
(S/D)
W–B
GR
W
22
Connector
Junction
D36
20
18 FD1 17 FD1 18 GD1 17 GD1
(S/D)
G
lec
GR
P
L
8 4D
8 4C 2 1 2 1
F6 G6
Speaker (Front Door RH) Speaker (Front Door LH)
SB
(S/D)
.ir
D3
223
YARIS (EM01V0U)
Audio System
J39 J38
Speaker (Rear LH) Speaker (Rear RH)
2 1 2 1
na
J27 J26
2 1 2 1
I4 H4
2 1 2 1
(S/D)
(S/D)
(S/D)
(S/D)
(∗2)
(∗2)
(∗2)
(∗2)
W
R
Y
B
(∗1)
(∗1)
(∗1)
(∗1)
W
W
R
R
5 IJ1 4 IJ1 5 HJ1 4 HJ1
sic (∗1)
(∗1)
(∗1)
(∗1)
W
R
Y
1 JD3 5 JD2 4 JD2 11 JD3 10 JD3 15 JD2 14 JD2 20 JD3

(H/B)
(H/B)
(H/B)
(H/B)
Y B W R
R
Y
(S/D) (S/D) (S/D) (S/D)
6 B 2 B 3 B 1 B
RL– RL+ RR– RR+
oe
ALI ARI ASGN AUXI
D10(A), D11(B), D74(C) 17 C 15 C 16 C 19 C
(Shielded)
R
∗ 1 : H/B 5–Door
∗ 2 : H/B 3–Door
1 2 3 4
ALO ARO ASGN AUXO
lec
D75
Stereo Jack Adapter
.ir
224
YARIS (EM01V0U)
: Parts Location
A25 48 (S/D) D36 53 (S/D) 56 (3–Door)
G6
C21 49 (S/D) 51 (H/B) 58 (4–Door)
D74 C
na
D1 53 (S/D) 53 (S/D) H4 54 (5–Door)
51 (H/B) 51 (H/B) I4 54 (5–Door)
D10 A D75
53 (S/D) 53 (S/D) J26 57 (3–Door)
51 (H/B) 54 (5–Door) J27 57 (3–Door)
D11 B
53 (S/D) F6 56 (3–Door) J38 59 (4–Door)
51 (H/B) 58 (4–Door) J39 59 (4–Door)
D32
53 (S/D) G6 54 (5–Door)
: Relay Blocks

sic
4C
30
4D Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
4M 31

AA2 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left)
oe
62 (H/B)
AD2
63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
AD3 63 (S/D)
CA2 61 (S/D) Engine Wire and Engine Room Main Wire (Engine Compartment Left)
62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
HJ1 64 (5–Door) Rear Door No.1 Wire and Floor Wire (Right Center Pillar)
IJ1 64 (5–Door) Rear Door No.2 Wire and Floor Wire (Left Center Pillar)
JD2 62 (H/B)
Floor Wire and Instrument Panel Wire (Instrument Panel Left)
lec
JD3 63 (S/D)
: Ground Points

A1 61 (S/D) Left Suspension Tower
62 (H/B)
63 (S/D)
.ir
225
YARIS (EM01V0U)
Combination Meter
(IG)
10A ECU–IG
na
24 4B
B
Junction Connector
16
D1(A), D2(B), D76(C)
Combination Meter
A25
20
sic
B
11 CA2
5V IC
B
CPU
oe (H/B)
(H/B)
I/F I/F I/F

I/F I/F
Clock
Buzzer SW TRIP
Drive SW
Monitor
3 A
11
P P P
lec
AD3
V
1 4C
6 AA2
W–B
3
B
and Gage Assembly
13 4A
Fuel Suction Pump
Gage
12 CA2 13 CA2 23 AA2

J5
W–B
W–B
2
BR
P
.ir
1 3 2 O
IG+ SI SE
C21
Speed Sensor A1 J1
226
YARIS (EM01V0U)
(BAT) (IG)
7. 5A 7. 5A
ECU–B MET
PANEL1
na
Fuse
2
1
30 4B 2 4S 1 4M
G
B
L
25
L L
AA2
G
16 B (H/B) D1(A), D2(B), D76(C)
2 A 1 A 14 A 16 C (S/D) Combination Meter
sic (H/B)
(H/B)
(H/B)
(H/B)
Pointer
Dial
Tail (Canada)
Display
Illumination I/F
CPU
Speedometer
oe
Tachometer
I/F I/F I/F
17 A 16 A 19 C 18 C 17 C 24 A
P
(S/D)
(S/D)
(S/D)
GR
lec
R
5 11 12
BR
SB
E TX+1 +S
ODO/TRIP SW
8 4C Clock SW
PBEW
8
4D D77 8
Hazard Warning
Signal SW
G
26 4B
20
D36
Junction
Connector
22 19
(S/D)
W
.ir
O
(S/D)
Assembly
Steering
Module
Control
Engine
Receiver
Power
ECU
Radio
D3
227
YARIS (EM01V0U)
228
Door
O
(∗4) (∗4)
(S/D)
D38(A), D39(B) P/S
(H/B)
(H/B)
Junction
Connector
2
LG GR (S/D)
16 B
16 A
7 A
Airbag
I/F
RV
ABS
8
Y
15 A
I/F
Combination Meter
TC
D29
Light Control MAINT REQD
CPU
Rheostat
na
Driver' s
Seat Belt
Temp. Hot
Temp. Cool
W
CAN I/F
21 A
LED Driver
CAN Controller
Combination Meter
sic
D1(A), D2(B), D76(C)
G Door
20 A
Graphic
(∗3) (∗3)
YARIS (EM01V0U)
Door
(Front LH)
(∗3) (∗3)
O
(S/D)
Door
(Front RH)
(∗3) (∗3)
oe
3
O
(H/B)
PBEW
Door
(Luggage)
9 C (S/D)
9 B (H/B)
D27 (∗3) (∗3)
Passenger Seat
Belt Warning Lamp
CRUISE
P
(∗5) (∗5)
lec
W
.ir
R
W
(∗5) (∗5)
N
(∗5) (∗5)
∗
∗
∗
∗
∗
5
4
3
2
1
D
(∗5) (∗5)
LED Driver
: S/D A/T
2
(∗5) (∗5)
: S/D w/ Tachometer
V V
2 B
2 C
L
: w/ Daytime Running Light
: S/D w/o Tachometer, H/B
19 AA2
18 AD3
(∗5) (∗5)
: w/o Daytime Running Light
na
A10
Brake Fluid Level
Warning SW
1
2
V
BRAKE (USA)
Brake (Canada)
W–B
Washer
Combination Meter
2
1
W–B W W
E
S
10 B
10 C
A1
D1(A), D2(B), D76(C)
22 AD3
sic
A22
(S/D)
Water Level Warning SW
YARIS (EM01V0U)
Y
22 C
Main Body ECU
(S/D)
Door
(Rear LH)
Door Courtesy SW G (∗3) (∗3)
20 C
(Rear LH)
oe
(S/D)
Door
(Rear RH)
Door Courtesy SW L (∗3) (∗3)
21 C
(Rear RH) (S/D) (S/D)
Charge
L
(∗2)
1 C (S/D)
1 B (H/B)
Generator
SB
lec
W
(∗1)
229
.ir
230
G
W
Head (USA)
Headlamp Dimmer SW L
13 B
13 C
Assembly
Oil Pressure
Y Y
12 B
12 C
18 AA2
19 AD3
Combination Meter
Y
na
Combination Meter
D1(A), D2(B), D76(C)
1
Y
6 CA1
C16
Engine Oil Pressure SW
Malfunction
Indicator Lamp
Engine Control B
4 B
4 C
Module
sic
Beam
Headlamp Dimmer SW P GR
14 B
14 C
Headlamps
Assembly
YARIS (EM01V0U)
11 C (S/D)
11 B (H/B)
Turn RH
BR
15 B
15 C
oe
FLASH Relay
Turn LH
LG
8 B
8 C
(S/D) (S/D)
Front Fog
(H/B) R
7 C (S/D)
7 B (H/B)
lec
W
.ir
D33 D31
Main Body ECU Power Steering ECU
na
1
PKB CANH CANL CANL CANH

24 23 22 7 1
C19
2
2 4C
SB
W
W
R
L
D16
Airbag Sensor A21(A), C20(B)
Assembly Center Engine Control Module 96 B 97 B
Y
5 16 15 4 ETHW THW
sic
CANH CANL CANH CANL NE+ NE–
41 A 49 A 122 B 121 B
Junction Connector
13 22
Parking Brake SW
W
L
D21
D42
7 18 22 11
15 AD4 16 AD4
W
G
P
L
W
W
Y
22 11 8 19 4 15
oe
Crankshaft Position
1
(Shielded)
Sensor
C2
2
17 6 D41 1 12
Junction Connector
W
W
G
V
lec
10 DE1 1 DE1 11 AD4 2 AD4
BR
W
W
G
V
3 2 6 5
TX– TX+ CANH CANL
E8 A15
A/C Amplifier Skid Control ECU
with Actuator
G
.ir
W
C1
231
YARIS (EM01V0U)
Combination Meter
: Parts Location
46 (H/B) C20 49 (S/D) 51 (H/B)
A10 D36
48 (S/D) 47 (H/B) 53 (S/D)
C21
na
46 (H/B) 49 (S/D) 51 (H/B)
A15 D38 A
48 (S/D) 51 (H/B) 53 (S/D)
D1 A
46 (H/B) 53 (S/D) 51 (H/B)
A21 D39 B
48 (S/D) D2 B 51 (H/B) 53 (S/D)
46 (H/B) 51 (H/B) 51 (H/B)
A22 D16 D41
48 (S/D) 53 (S/D) 53 (S/D)
46 (H/B) 51 (H/B) 51 (H/B)
A25 D21 D42
48 (S/D) 53 (S/D) 53 (S/D)
47 (H/B) D27 51 (H/B) D76 C 53 (S/D)
C2
49 (S/D) 51 (H/B) D77 53 (S/D)
D29
47 (H/B) 53 (S/D) 50 (H/B)
C16 E8
sic
49 (S/D) 51 (H/B) 52 (S/D)
D31
47 (H/B) 53 (S/D) 55 (5–Door)
C19
49 (S/D) 51 (H/B) J5 57 (3–Door)
D33
C20 47 (H/B) 53 (S/D) 59 (4–Door)
: Relay Blocks

oe
4C
30
4D
4M
31
4S

62 (H/B)
63 (S/D)
lec
62 (H/B)
AD3
63 (S/D)
62 (H/B)
AD4
63 (S/D)
60 (H/B)
CA1
61 (S/D)
60 (H/B)
CA2
61 (S/D)
62 (H/B)
63 (S/D)
.ir
232
YARIS (EM01V0U)
: Ground Points

60 (H/B)
61 (S/D)
na
60 (H/B)
61 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
J1 65 (3–Door)
sic
oe
lec
.ir
233
YARIS (EM01V0U)
Cooling Fan
(BAT) (IG)
30A 10A
RDI ECU–IG
na
2
1 24 4B
B
L
Junction Connector
16
B 17
A25
18
sic
LG
B
5 1B 6 1B 1 1
2 3
FAN NO. 1 FAN NO. 2 4

Relay Relay
1 5
oe
8 1B 7 1B 1 1 1
W–B
LG
O
L
Radiator Fan Resistor

Cooling Fan Motor
2
2
3 AA2 4 AA2
M
A8
A14
lec
1
1
LG
O
W–B
LG
W–B
LG
O
.ir
W–B
A2 A1
234
YARIS (EM01V0U)
E8
A/C Amplifier
TX– TX+ SG–1 S5–3 PRE
na
3 2 11 1 6
GR
W
Y
10 DE1 1 DE1 9 AE1 4 AE1 3 AE1
GR
W
Y
sic
17 6 6
Connector
Connector
Junction
Junction

D41
A25
15 4 5
1
W
B
L
A/C Pressure Sensor
C19
1 3 2
16 AD4 15 AD4 – + PR 2
W
P
L
L
oe
A3
49 A 41 A 96 B 97 B
CANL CANH ETHW THW
FAN2 FAN NE+ NE–

22 A 21 A A21(A), C20(B) 122 B 121 B
(Shielded)
lec
LG
P
L
Crankshaft Position
LG
Sensor
O
C2
2
.ir
BR
C1
235
YARIS (EM01V0U)
Cooling Fan
: Parts Location
46 (H/B) A21 A 48 (S/D) 47 (H/B)
A3 C20 B
48 (S/D) 46 (H/B) 49 (S/D)
A25
na
46 (H/B) 48 (S/D) 51 (H/B)
A8 D41
48 (S/D) 47 (H/B) 53 (S/D)
C2
46 (H/B) 49 (S/D) 50 (H/B)
A14 E8
48 (S/D) 47 (H/B) 52 (S/D)
C19
A21 A 46 (H/B) 49 (S/D)
: Relay Blocks


sic

62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
62 (H/B)
oe
63 (S/D)
62 (H/B)
63 (S/D)
: Ground Points

60 (H/B)
A1
61 (S/D)
60 (H/B)
A2
61 (S/D)
60 (H/B)
lec
61 (S/D)
.ir
236
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
237
YARIS (EM01V0U)
Air Conditioning
(BAT) (IG)
∗ 1 : w/ PTC Heater
∗ 2 : w/o PTC Heater
40A 10A ∗ 3 : w/ Defroster Mode Detection SW
HTR GAUGE ∗ 4 : w/o Defroster Mode Detection SW
∗ 5 : w/ A/C SW
na
∗ 6 : w/o A/C SW
2
5 2
4 HTR
Relay
L
3 1
1 4L 17 4E 7 4F 5 4Q
sic
B
1 ED1 BR
B
2
13 DE1
M E4
Blower Motor
1
oe
BR
L
E3
Blower Resistor
L 4
W–B
2 3 1
L
W–B
G
Connector 1
Junction
2 BR
E10
3
10 6 7
E LO HI M2 M1
R
lec
0
1
W–B
3
Blower SW
2 ED1
4
E1
5 9
W–B
W–B
.ir
D1 D2
238
YARIS (EM01V0U)
E5
A/C SW
(IG)
L B
A/C SW
7. 5A
A/C Off
na
On
(∗3 ∗5) (∗5)

10 4S
L B
Detection
Defroster
O
(∗4 ∗5)
(∗5)
Off
Mode
SW
(∗3 ∗5)
On
12 DE1
(∗3 ∗5)
(∗3 ∗5) (∗6)

sic
O L B E
2 4 3
E10
P 17
LG
V
P
18 16
E6
Rear Window
Y
Defogger SW 3
IG+ E8(A), E9(B)
8 A A/C Amplifier 15 A 16 A
IG+ A/C LED
IG MAX–
HOT
Max
SW
Hot
Off
oe
On HEAT B/V SBLW GND SG–2 TE
14 B 14 A 9 A 12 A 4 A 10 A
SG A/C B
8 7 6
LG
W–B
(∗2)
(∗2)
(∗2)
(∗2)
BR
LG
LG
L
(∗1)
4
Connector
Junction
BR
E10
5
14
Connector
Junction
L 12
E10
(∗2)
lec
13
W–B
GR
9 DE1
(∗2)
(∗1)
L
L
W–B
Junction Connector
5
A/C Thermistor No. 1
1
D40
11
W–B
E2
2
.ir
3 6A
D2
239
YARIS (EM01V0U)
Air Conditioning
Main Body ECU
Generator
na
D33
HRLY M
C9
3 3
(∗1)
(∗1)
LG
P
8
Connector
Junction
D40
15 CA1
7
(∗1)
(∗1)
LG
P
sic
14 DE1 7 AE1
(∗1)
(∗1)
LG
P
E8(A), E9(B)
A/C Amplifier 23 B 24 B
HLS ALT
oe
TX+ TX– TAM SG–1 S5–3 PRE
2 A 3 A 5 A 11 A 1 A 6 A
W
V
GR
W
1 DE1 10 DE1 10 AE1 9 AE1 Y

4 AE1 3 AE1
GR
W
W
V
6 17 3 2
Connector
Junction
10 BA1 + PR
D41
Crankshaft Position
lec
2
4 15
W
–
W
L
2
Sensor
1 A3
A/C Pressure
C2
Ambient Temp.
Sensor
1
15 AD4 16 AD4
B
B
Sensor
B5
6 5
1
(Shielded)
A25
Junction
W
P
L
Connector
B
122 B 121 B 41 A 49 A 11 BA1

B
NE+ NE– CANH CANL

.ir
A21(A), C20(B)
BR
C1
240
YARIS (EM01V0U)
(BAT) (BAT)
40A 30A
HTR HTR
SUB2 SUB1
na
2 2
1 1
(∗1)
W
R
W(∗1)
R(∗1)
(∗1)
W
2 2 2 2 1 1
(∗1)
(∗1)
O
R
2 5 2 5 1 5
sic
W–B
(∗1)
HTR HTR HTR
SUB2 SUB3 SUB1
2 AE1 5 AE1 Relay Relay Relay
1 3 1 3 2 3
2 2 2 2 1 1
(∗1)
(∗1)
BR
R
W–B
(∗1)
(∗1)
(∗1)
V
B
W–B
12 B 10 B (∗1)
PTC3 PTC2
L
(∗1)
R
E8(A), E9(B) (∗1)

A/C Amplifier
oe
3 1 2
SOL+ PTC1 B B B
7 A 9 B
(∗1)
LG
1 AE1
V
A17
PTC Heater
6 AE1
LG
7 CA1
lec
LG
1
C8
A/C Compressor
2
W–B
2 CA1
W–B
.ir
W–B
(∗1)
W–B
A1
241
YARIS (EM01V0U)
Air Conditioning
: Parts Location
46 (H/B) 47 (H/B) 50 (H/B)
A3 C9 E3
48 (S/D) 49 (S/D) 52 (S/D)
na
50 (H/B) 47 (H/B) 50 (H/B)
A17 C20 B E4
52 (S/D) 49 (S/D) 52 (S/D)
46 (H/B) 51 (H/B) 50 (H/B)
A21 A D33 E5
48 (S/D) 53 (S/D) 52 (S/D)
46 (H/B) 51 (H/B) 50 (H/B)
A25 D40 E6
48 (S/D) 53 (S/D) 52 (S/D)
46 (H/B) 51 (H/B) 50 (H/B)
B5 D41 E8 A
48 (S/D) 53 (S/D) 52 (S/D)
47 (H/B) 50 (H/B) 50 (H/B)
C2 E1 E9 B
49 (S/D) 52 (S/D) 52 (S/D)
47 (H/B) 50 (H/B) 50 (H/B)
C8 E2 E10
sic
49 (S/D) 52 (S/D) 52 (S/D)
: Relay Blocks

4E
4F
oe
4L 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel)
4Q
4S

62 (H/B)
63 (S/D)
62 (H/B)
63 (S/D)
lec
60 (H/B)
61 (S/D)
60 (H/B)
61 (S/D)
62 (H/B)
63 (S/D)
62 (H/B)
ED1 Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Left)
63 (S/D)
.ir
242
YARIS (EM01V0U)
: Ground Points

60 (H/B)
61 (S/D)
na
60 (H/B)
61 (S/D)
62 (H/B)
D1 Left Kick Panel
63 (S/D)
62 (H/B)
D2 Right Kick Panel
63 (S/D)
sic
oe
lec
.ir
243
YARIS (EM01V0U)
I GROUND POINT
W–B
A15 (GND2)
Skid Control
ECU with Actuator
W–B
W–B W–B
(GND1) (PGND) A19
Power Steering
na
ECU
A2 A3
W–B
23 13
W–B W–B W–B
AA2 CA2 (SE) C21
W–B Speed Sensor
A21 (EC)
3
W–B W–B
A22 (E) 1A EFI Relay
sic
3
W–B
W–B
1B IG2 Relay
2
W–B W–B
CA1 (SOL–) C8
A/C Compressor
W–B
6
W–B W–B
AD5 (E) D9
Running Light
Relay
oe
A1 W–B
(E) A10
W–B
Brake Fluid Level

Warning SW
W–B
(L) A14
Radiator Fan
Resistor
W–B W–B
A2 (E) 2 (L) H–LP/AMT
Turn Signal Lamp (H/B) Relay
(Front Side LH)
W–B W–B
A1 (E) (E) A9
Turn Signal Lamp (H/B) Windshield Wiper
(Front Side RH) Motor
lec
W–B W–B
A18 (GND) 1 (–S) HTR SUB1
Engine Hood Courtesy SW Relay
W–B
W–B W–B
A23 (L) 2 (–S) HTR SUB3
Security Horn Relay
W–B
W–B
ST Relay (–S) 1 2 (–S) HTR SUB2
Relay
W–B
1 (E) FAN NO. 2
Relay
.ir
8
W–B W–B
BA1
244
YARIS (EM01V0U)
I
D34
Junction Connector B
(E02) C20
BR 7 6 Engine Control
D3 (ECC)
Spiral Cable (∗1) Module
5
W–B
(GND) C14
BR Ignition Coil
na
(∗1) (No. 4)
(∗1)
BR
BR
D15 (SG)
Data Link (∗2) W–B W–B
(GND) C11
Connector 3 Ignition Coil
(No. 1)
BR
J25 (MGND)
Canister Pump W–B
(GND) C12
Module Ignition
Coil (No. 2)
3 AJ1 6 AD2
(Shielded)
W–B
(GND) C13
Ignition Coil
BR
BR
(No. 3)
5 AA1 13 CA1
sic BR
BR
BR
B
14 CA2
BR
C1
BR BR
C20 (E01)
Engine Control
Module
BR
(ME01)
oe
W–B
(E03)
W–B
BR
BR
W–B
(E04)
W
(E1)
C2
W–B W–B
B1 (E) (E) B11
Turn Signal Lamp (H/B) (H/B) Side Marker Lamp
lec
(Front RH) (Front RH)
W–B W–B
B8 (E) (E) B12
Turn Signal Lamp (H/B) (H/B) Side Marker Lamp
(Front LH) (Front LH)
W–B W–B
B9 (E) (E) B7
Fog Lamp (Front RH) (H/B) Parking Lamp (LH)
W–B W–B W–B

B10 (E) (E) B3
Fog Lamp (Front LH) (H/B) Parking Lamp (RH)
W–B W–B
(E) B14
(S/D) (S/D) Turn Signal,
Side Marker and
Parking Lamp (RH)
.ir
W–B
W–B
(E) B15
(S/D) Turn Signal,
W–B W–B Side Marker and
Parking Lamp (LH)
B1
245
YARIS (EM01V0U)
I GROUND POINT
na
FLASH Relay
28
W–B
D4 (E) 4E (GND1) Main Body ECU
Headlamp Dimmer
SW Assembly
12
W–B
(ED) 4E NOISE FILTER
1
W–B W–B
K2 (E) 4K IG 1 Relay
Room Lamp (Center)
sic
W–B
K1 (L) PWR Relay
Map Lamp
2
W–B
D5 (EW) 4E HTR Relay
1 17
W–B W–B
4S JD1
(S/D) (S/D)
30 15 J24
W–B W–B W–B Occupant
D16 (E1) 4E 4A (GND)
Airbag Sensor Classification
Assembly Center ECU
oe
14 7
W–B W–B
(E2) 4E 4M
(S/D)
W–B
17 12 H3
W–B Door Lock Assembly
4E HJ1 (E)
(S/D) (Rear RH)
12 I3
W–B W–B Door Lock Assembly
IJ1 (E)
(S/D) (S/D) (Rear LH)
lec W–B
4
W–B
G7 (E) 5B
Door Lock Control (S/D)
SW (Driver Side) W–B
4
W–B
D12 (E) 5A
Outer Mirror SW
W–B
(CG) D15
1 Data Link
W–B Connector 3
D19 (UN–) 5A
Unlock Warning SW
W–B
W–B
1
W–B
G5 (E) 5B
Door Lock Assembly
(Driver' s Side)
.ir
3
W–B
G1 (E) 5B
Power Window Master SW W–B
D1
246
YARIS (EM01V0U)
I
W–B 4
E8 (GND)
A/C Amplifier E10
Junction Connector
W–B 7
E6 (E)
Rear Window
na
Defogger SW 5
W–B
W–B
D77 (E)
Hazard Warning (S/D) 9 DE1
Signal SW
W–B
W–B W–B W–B
D7 (E) (E) D14
Hazard Warning (H/B) (H/B) Cigarette Lighter
Signal SW or Power Outlet
W–B W–B
D13 (KLS–) (E) D25
Key Interlock Solenoid Security Indicator
sic
Lamp
W–B
(GND) D23
Transponder
Key ECU
W–B
W–B
5
W 9 13 W–B
D27 (ILL–) (E) D30
Passenger Seat (H/B) (H/B) Door Lock
Belt Warning Lamp Control SW
W–B 10 12 W–B
D26 (E) (E) D22
Theft Warning ECU Shift Lock
11 D40 Control ECU
oe
Junction Connector
W–B
W–B
3 6A
5 4
W–B
6A 6A (T1) D4
Headlamp Dimmer
SW Assembly
lec
2 6
W–B W–B
D29 6A 6A (E) D14
Light Control Rheostat (S/D) Cigarette Lighter
or Power Outlet
1 1
W–B W–B W–B
6A 6B (E) F5
Door Lock
Assembly (Front
Passenger' s Side)
F7 6
Door Lock Control W–B
(E) 6B
SW (Front (S/D)
Passenger' s Side)
2
W–B W–B W–B
ED1 (E) E1
Blower SW
W–B
(E) E3
.ir
Blower Resistor
W–B W–B
D2
247
YARIS (EM01V0U)
I GROUND POINT
W–B W–B
J5 (E) (E) N2
Fuel Suction (H/B) Back Door
Pump and Courtesy SW
Gage Assembly
BR W–B W–B
(FE) (LSWE) N4
(H/B) (H/B) Back Door
na
Position SW
W–B
J3 (E)
Rear Combination (H/B) N1
Lamp (RH)
W–B
J34 (E)
Rear Combination (S/D)
Lamp (RH)
J1
(H/B)
W–B
W–B
W–B
(E) J40
(S/D Bulb) Center Stop
Lamp
W–B
J41
sic
(E2)
(S/D LED) Center Stop
Lamp
(S/D)
W–B
8 MN1
W–B
(L) J43
(S/D) Door Lock Assembly
(Luggage)
(H/B)
(S/D)
W–B
B
W–B
(E) J42
(S/D) Door Lock Assembly
(Luggage)
W–B
(S/D)
W–B
(E) J36
(S/D) License Plate
Lamp (RH)
W–B
(E) J37
(S/D) License Plate
oe
Lamp (LH)
W–B
(S/D)
W–B
(E) J35
(S/D) Rear Combination
Lamp (LH)
W–B
(GND) J13
7 MJ1 Door Control
Receiver
W–B
(H/B)
W–B
W–B
(E) J4
(H/B) Rear Combination
Lamp (LH)
11
W–B W–B
MJ1 (E) M1
(H/B) (H/B) Center Stop Lamp
lec
9
W–B W–B
LJ1 (E) L1
W–B
(H/B) (H/B) License Plate

Lamp
W–B
J2
W–B
D10 (GND)
Radio Receiver
Assembly
BR B
D1 (ET) (E) O1
.ir
Combination Meter Rear Window
Defogger
D3 O1
248
YARIS (EM01V0U)
I
: Parts Location
D34 53 (S/D) D40 53 (S/D) E10 52 (S/D)
D40 51 (H/B) E10 50 (H/B)
na
: Relay Blocks

1A
25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
1B
sic
4M
4S
oe
lec
.ir
249
YARIS (EM01V0U)
I GROUND POINT
62 (H/B)
AA1
63 (S/D)
na
62 (H/B)
AA2
63 (S/D)
62 (H/B)
AD2
63 (S/D)
62 (H/B)
AD5
63 (S/D)
62 (H/B)
63 (S/D)
60 (H/B)
61 (S/D)
60 (H/B)
CA1
sic
61 (S/D)
60 (H/B)
CA2
61 (S/D)
62 (H/B)
63 (S/D)
62 (H/B)
ED1 Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Left)
63 (S/D)
HJ1 66 (4–Door) Rear Door No.1 Wire and Floor Wire (Right Center Pillar)
IJ1 66 (4–Door) Rear Door No.2 Wire and Floor Wire (Left Center Pillar)
JD1 63 (S/D) Floor Wire and Instrument Panel Wire (Instrument Panel Left)
64 (5–Door)
LJ1 Luggage Room No.2 Wire and Floor Wire (Luggage Room Left)
65 (3–Door)
oe
64 (5–Door)
65 (3–Door)
64 (5–Door)
65 (3–Door)
lec
.ir
250
YARIS (EM01V0U)
I
: Ground Points

60 (H/B)
A1
61 (S/D)
na
60 (H/B)
A2
61 (S/D)
62 (H/B)
A3 Left Cowl Top Side Panel
63 (S/D)
60 (H/B)
61 (S/D)
60 (H/B)
C1
61 (S/D)
Engine Block Left
60 (H/B)
C2
61 (S/D)
62 (H/B)
sic
D1 Left Kick Panel
63 (S/D)
62 (H/B)
D2 Right Kick Panel
63 (S/D)
62 (H/B)
63 (S/D)
64 (5–Door)
J1 65 (3–Door)
64 (5–Door)
J2 65 (3–Door)
oe
64 (5–Door)
65 (3–Door)
64 (5–Door)
Back Door Panel Left
O1 65 (3–Door)
66 (4–Door) Right Rear Quarter Panel
lec
.ir
251
YARIS (EM01V0U)
The chart below shows the route by which current flows from the battery to each electrical source
(Fusible Link, Circuit Breaker, Fuse, etc.) and other Parts.
Headlamp Dimmer
10A TAIL 2 SW Assembly D4
(*2) (*2) (*2)
na
DEF Relay
30A DEF 2 (Point Side) 2
30A ABS2/VSC2
30A HTR SUB1
30A RDI
40A HTR 1
7.5A OBD2
40A HTR SUB2
10A STOP
sic
2 50A ABS1/VSC1
15A FR FOG
50A EPS
25A D/L
Ignition SW
Battery 120A ALT 3 25A AM1 2 (AM1) D8
10A TAIL
T-LP Relay
(Point Side) 2 2
(*1) (*1) 7.5A PANEL1
IG 1 Relay
(Point Side) 2
oe
30A POWER
PWR Relay
(Point Side) 2 20A RL DOOR 2
20A RR DOOR
EFI Relay
60A MAIN 3 20A EFI 1 (Point Side) 1
15A AM2 1
lec
10A HORN 1 7.5A ALT-S
7.5A ECU-B
10A ETCS
10A HAZ
1
10A
H-LP LH/H-LP LO LH
10A
H-LP RH/H-LP LO RH
15A DOME
30A ST
.ir
252
YARIS (EM01V0U)
J
7.5A PANEL2 2 7.5A PANEL1 2 Example

(*2) (*2)
na
10A ID/UP/MIR HTR 2 Starter S1
Parts Code or Location
7.5A DRL 4
Location
Electrical Source
sic
7.5A ACC2 4
7.5A ACC
ACC Cut Relay D45 2
15A CIG
7.5A A/C
10A ECU-IG
10A GAUGE
2
oe
15A RR WIP
15A WSH
25A WIP
10A EFI2 1
7.5A IGN
IG2 Relay
(Point Side) 1 2
7.5A MET
lec
* 1:H/B, S/D *3
* 2:Except *1
* 3:Cold Area Spec ., w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger,
w/ Door Lock Control, w/ Daytime Running Light, w/ Remote Control Mirror,
w/ Air Conditioning
[LOCATION]
1 : Engine Room R/B and Engine Room J/B (See Page 24)
2 : Instrument Panel J/B (See Page 30)
.ir
3 : Fusible Link Block (See Page 42)
4 : Fuse Block (See Page 45)
253
YARIS (EM01V0U)
Engine Room R/B and Engine Room J/B (See Page 24)
Fuse System Page
7.5A ALT–S Charging 78
na
Cruise Control 102
Door Lock Control 184
Electronically Controlled Transmission and A/T Indicator 96
Engine Control 84
Engine Immobiliser System 110
Headlight 120
7.5A ECU–B
Interior Light 128
Key Reminder and Light Reminder 150
sic
Power Window 178
Seat Belt Warning 168
SRS 159
Theft Deterrent 200
Wireless Door Lock Control 192
10A EFI2 Engine Control 84
10A ETCS Engine Control 84
10A HAZ Turn Signal and Hazard Warning Light 124
Headlight 120
Theft Deterrent 200
oe
10A H–LP RH/H–LP LO RH Headlight 120
Horn 144
10A HORN
Theft Deterrent 200
Engine Control 84
15A AM2 Ignition 80
Starting 74
Audio System 222
Engine Control 84
lec
15A DOME Interior Light 128
Theft Deterrent 200
Cruise Control 102
20A EFI Electronically Controlled Transmission and A/T Indicator 96
Engine Control 84
30A ABS2/VSC2 ABS 154
30A HTR SUB1 Air Conditioning 238
30A RDI Cooling Fan 234
30A ST Starting 74
.ir
40A HTR Air Conditioning 238
40A HTR SUB2 Air Conditioning 238
50A ABS1/VSC1 ABS 154
∗ These are the page numbers of the first page on which the related system is shown.
254
YARIS (EM01V0U)
J
Fuse System Page
50A EPS EPS 174
Instrument Panel J/B (See Page 30)

na
Fuse System Page
Air Conditioning 238
7.5A A/C
Rear Window Defogger 216
Audio System 222
Interior Light 128
7.5A ACC
Remote Control Mirror 218
Theft Deterrent 200
sic
Cruise Control 102
Engine Control 84
7.5A IGN
Engine Immobiliser System 110
SRS 159
ABS 154
Audio System 222
Charging 78
oe
Cruise Control 102
7.5A MET Engine Control 84
EPS 174
Interior Light 128
SRS 159
Taillight and Illumination 134
lec
7.5A OBD2 Data Link Connector 3 112
7.5A PANEL1
7.5A PANEL2
ABS 154
Audio System 222
Cooling Fan 234
10A ECU–IG
Cruise Control 102
.ir
Engine Control 84
255
YARIS (EM01V0U)
Fuse System Page
EPS 174
Headlight 120
10A ECU–IG Power Window 178
na
Theft Deterrent 200
Air Conditioning 238
Back–Up Light 140
Charging 78
Cruise Control 102
10A GAUGE Rear Window Defogger 216
sic
Shift Lock 214
SRS 159
Turn Signal and Hazard Warning Light 124
10A ID/UP/MIR HTR Engine Control 84
ABS 154
Cruise Control 102
10A STOP
Engine Control 84
oe
Shift Lock 214
Stop Light 142
Engine Control 84
10A TAIL Key Reminder and Light Reminder 150
15A CIG Cigarette Lighter/Power Outlet 220
Front Fog Light 146
15A FR FOG
Headlight 120
15A RR WIP Rear Wiper and Washer 212
lec
Front Wiper and Washer 208
15A WSH
Rear Wiper and Washer 212
20A RL DOOR Power Window 178
20A RR DOOR Power Window 178
20A WIP Front Wiper and Washer 208
Interior Light 128
25A D/L
Theft Deterrent 200
Engine Control 84
.ir
30A DEF
Rear Window Defogger 216
30A POWER Power Window 178
256
YARIS (EM01V0U)
J
Fusible Link Block (See Page 42)

Fuse System Page
Charging 78
na
Engine Control 84
120A ALT Key Reminder and Light Reminder 150
Power Window 178
Fuse Block (See Page 45)

Fuse System Page
7.5A ACC2 Shift Lock 214
sic
oe
lec
.ir
257
YARIS (EM01V0U)
K CONNECTOR LIST
A1 A2 A3 A4 A5
Gray Gray Black Gray Black
1 2 1 2
1 2 3 1 2 1 2
na
A6 A7 A8 A9 A10
Yellow Gray Gray
1 2 1 2 1 2
1 2 3
1 2 4 5
sic
A11 A12 A13 A14
Yellow Black
1 2 1 2 1 2
3 4 1 2
A15 A16 A17 A18

Black Black Black
oe
1 2
1 2
1 2 3
3 4 5 6 7 8 9 10 11 12
1 2
13 14 15 16 17 18 19 20 21 22
23 24
25 26 27 28 29 30 31 32 33 34
lec
A19 A20 A21
Gray Black Black
1 2 3 4 5 6
1 1 2 4 5 6 7 8 9 10 11
3
12 13 14 15 16 17 18 19
2 20 21 22 23 24 25 26 27 28 29 30
31 32 33 34 35 36 37 38 39 40 41
42 43 44 45 46 47 48 49
50 51 52 53 54 55 56 57 58 59 60
.ir
258
YARIS (EM01V0U)
K
A22 A23 A24
Black Black
1 2
1 2
na
1 2 3 4 5 6
7 8 9 10 11 12
A25 A26 A27

Black Black
1 2 3 4 1 2
sic
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
A28 A29 B1 B2 B3 B4
Gray Black Brown
1
1
1 2 2 3
1 2
1 2
1
oe
B5 B6 B7 B8 B9
Black Brown Gray Black
1
2 3 1 2
1 2 1 2 1 2
B10 B11 B12 B13

lec
Black Gray Gray
1 2 1 2 1 2
1 2 3 4 5 6
7 8 9 10 11 12
B14 B15 C1 C2 C3
Gray Gray Black Blue
.ir
1
1 2 1 2
3 4 3 4 1 2 1 2
259
YARIS (EM01V0U)
K CONNECTOR LIST
C4 C5 C6 C7 C8
Black Gray Black Gray Gray
1 2 1 2 1 2 1 2
1 2
na
C9 C10 C11 C12 C13
Black Black Gray Black
1
1 2 1 2 3 4 1 2 3 4 1 2 3 4
3 4
sic
C14 C15 C16 C17 C18
Gray Black Gray Black Black
1 2 3 4 1 1 2 3 4 5 6 1 2
1
C19 C20
Black Black
oe
1 2
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 41 42 43 44 45 46
64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86
87 88 89 90 91 92 93 94 95 96 97 98 99100101102103
110111112113114115116117118119120121122123124125126 104105106107108109
lec
C21 C22 C23 C24 C25
Black Gray Dark Gray Black Gray
1 2 3 1 2 1 2
1 2 3 4 1 2
C26 C27 C28 C29

Black Gray Gray Black
.ir
1 2 3 4 5
1 2 3 4 1 2 3 4 5 1 2
5 6 7 8 9 6 7 8 9 10
260
YARIS (EM01V0U)
K
C30 D1 D2 D3
1
na
1 2 3 4 5 6 7 8 1 2 3 4 5 6
1 2 3 4 5 6 7 8 9 10 11 12
9 10 11 12 13 14 15 16 7 8 9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
D4 D5 D6 D7
Gray
1 2 3 4
5 6 7 8 9 10 11 12 13 1 2 3 1 2 3 4
1 2 3 4
4 7 5 10
56 6789
sic
D8 D9 D10 D11
Blue
1 2 3 4 1 2
3 4 5 6 7 8 9 10 11 5 6 7 8 9 10 3 4 5 6
1 2 3 4 1 2 12 13 14 15 16 17 18 19 20
5 6 7 8
oe
D12 D13 D14 D15
Black
1 2
1 2
1 2 3 4 5 6 7 8 9 10
16 15 14 13 12 11 10 9
8 7 6 5 4 3 2 1
lec
D16 D18 D19 D20 D21
Yellow Yellow
1 2 3 4 5 6 7 8 9 10
1 2 1 2 1
1 2 3 4
11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30
.ir
261
YARIS (EM01V0U)
K CONNECTOR LIST
D22 D23 D24 D25
Black Black
1 2
1 2 3 4 5 1 2 3 4 5 6 7 3 4
na
1 2 3 4 5 6
6 7 8 9 10 11 12 13 14 15 16 5 6
7 8 9 10 11 12
D26 D27 D28 D29

Dark Gray
1 2
1 2 3
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 3 4
4 5 6 1 2 3 4 5
16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36
6 7 8 9 10
sic
D30 D31 D32 D33
1
1 2 3 4 5 6 1 2 3 10 11 12
1 2 3 4 5 6 7 8 4 5 6 7 8 9
7 8 9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24 25 26
oe
D34
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
lec
D35
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
.ir
262
YARIS (EM01V0U)
K
D36
na
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
D37
sic
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
D38
oe
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
D39
lec
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
D40
.ir
1 2 3 4 5
6 7 8 9 10111213
263
YARIS (EM01V0U)
K CONNECTOR LIST
D41
na
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
D42 D43 D44

Black
1 2
1 2 3 4
sic
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
D45 D46 D74 D75

Gray Gray
3 3
5 5
1 2 3 4 5 6 7 8 9 10 1 2 3 4
1 4 2 1 2 11 12 13 14 15 16 17 18 19 20
oe
D76 D77 E1
1 2 3 4 5 1 5
2 3 4
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
6 7 8 9 10 11 12 13 14 15 16 6 7 8 9 10
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
lec
E2 E3 E4 E5 E6
Black Black
12
1 2
1 2 1 2 3 4 5 6 7 8
3 4 1 2 3 4 5 6 7 8
E8 E9
.ir
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8 9 10 11 12
9 10 11 12 13 14 15 16
13 14 15 16 17 18 19 20 21 22 23 24
264
YARIS (EM01V0U)
K
E10 F1 F2
1 2 3 4 5 2 1 3
na
1 2 3 4 5 6 7 8 9 10 11 5 4
12 13 14 15 16 17 18 19 20 21 22
F4 F5 F6 F7
sic
1 2
1 2 3 4 1 1 2 3 4
3 4 5 6
5 6 7 8 9 10 2
G1 G2 G4 G5
1 2
2 1 3 1 2 3 4
3 4 5 6
1 2 3 4 5 6 7 8 9
5 4 5 6 7 8 9 10
10 11 12 13 14 15 16 17 18
oe
G6 G7 H1 H2 H3 H4
12345
1 2
1 1 2 3 4 1 2 3 4 1
3 4 5 6
lec
2 5 6 7 8 9 10 2
I1 I2 I3 I4 J1 J2
12345
1 2 1 1
1 2 3 4 1
3 4 5 6
5 6 7 8 9 10 2
.ir
265
YARIS (EM01V0U)
K CONNECTOR LIST
J3 J4 J5 J8 J9
Yellow Yellow
1 2 3 4 5 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 5 6 1 2 3
na
4 5 6 7 8 9 10 6 7 8 9 10
11 12 13 14 15 11 12 13 14 15
J10 J11 J12 J13 J14

Yellow
1 2
1 2 1 2 1 2
3 4 3 4 1 2 3 4 5
sic
J15 J16 J17 J20 J21
Yellow Yellow Yellow Yellow Yellow
1 2 1 2
1 2 1 2 3 4 1 2 3 4
oe
J22 J23 J24 J25 J26
Black Black Black Black
1 2 1 2 1 2 3 4 5 6 1 2 3 4 5 1
7 8 9 101112 6 7 8 9 10
2
J27 J28 J29

lec
1
2
1 2 3 4 5 6 1 2 3 4 5 6
7 8 9 10 11 12 7 8 9 10 11 12
J30 J31 J32 J33 J34 J35

Black
.ir
1 2
1 1 1 2 1 2
1 2
3 4 5 6 3 4 5 6
266
YARIS (EM01V0U)
K
J36 J37 J38 J39 J40 J41
Gray Gray Gray
1 2 1 2 1 2
2 1 2 1
na
2 1
J42 J43 J44 J45 K1 K2

Black Black Gray
1 1 2 3
12 12
1 2 3 1 2
sic
L1 M1 M2 N1 N2 N3
Gray Black
1
1 2
1 2 1 2 1 2 1 2
3 4
N4 O1 O1 P1 Q1 Q2
(H/B) Black (S/D) Black Black Orange Black
oe
1 1
1 2
1 2 3 4 1 2 1 2
U1 U2 U3 U4 U5
Gray Black Black Black Black
lec
1 2 3 4 5 6 1 2 3 1 2 3 1 2 3 1 2 3
7 8 9 101112
.ir
267
YARIS (EM01V0U)
K CONNECTOR LIST
V1 V1 W1 W2 X1 Y1
(H/B) (S/D) Orange Black
1 2 1 2 1 2 1 2
na
1 2 3 4 5
1 2
6 7 8 9 10
3 4
Z1 a1 b1 c1
Black Black
1 2 1 2
1 1 2 3 4
5 6 7 8
sic
2
oe
lec
.ir
268
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
269
YARIS (EM01V0U)
K CONNECTOR LIST
AA1 AA2
na
1 2 3 4
5 6 7 8 9 10 4 3 2 1 1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1
10 9 8 7 6 5
17 10 11 12 13 14 15 16 25 25 16 15 14 13 12 11 10 17
18 19 20 21 22 23 24 24 23 22 21 20 19 18
AD1 Yellow AD2

sic
2 1
4 3 1 2 3 4 5 5 4 3 2 1
1 2
6 7 8 9 10 10 9 8 7 6
3 4
AD3 Black
oe
11 10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9 10 11
22 21 20 19 18 17 16 15 14 13 12
12 13 14 15 16 17 18 19 20 21 22
AD4 Gray AD5 Blue

lec
9 8 7 6 5 4 3 2 1 5 4 3 2 1
1 2 3 4 5 6 7 8 9 1 2 3 4 5
18 17 16 15 14 13 12 11 10 9 8 7 6
10 11 12 13 14 15 16 17 18 6 7 8 9
1716151413121110
1011121314151617
.ir
270
YARIS (EM01V0U)
K
AE1 AJ1
na
1 2 3 4
5 6 7 8 9 10 4 3 2 1 1 2 3 4 5 6 7 7 6 5 4 3 2 1
10 9 8 7 6 5 8 9 10 11 12 13 14 14 13 12 11 10 9 8
BA1 CA1
sic
5 4 3 2 1
1 2 3 4 5 1 2 2 1
9 8 7 6 5 5
3 4 6 7 7 6 4 3
6 7 8 9
8 9 10 11 12 12 11 10 9 8
1716151413121110 13 14 15 15 14 13
1011121314151617
CA2 CP1 Gray

oe
1 2 2 1
5 4 3 2 1
1 2 3 4 5
9 8 7 6
6 7 8 9
1716151413121110
1011121314151617
lec
DE1 DQ1 Yellow
4 3 2 1
9 8 7 6 5 4 3 2 1 1 2 3 4
1 2 3 4 5 6 7 8 9
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
.ir
271
YARIS (EM01V0U)
K CONNECTOR LIST
ED1 FD1
na
1 2 2 1
1 10 10 1
11 2 3 4 5 6 7 8 9 20 20 9 8 7 6 5 4 3 2 11
12 13 14 15 16 17 18 19 19 18 17 16 15 14 13 12
FD2
sic
1 2 8 9 9 8 2 1
10 11 3 4 5 6 7 17 18 18 17 7 6 5 4 3 11 10
12 13 14 15 16 16 15 14 13 12
GD1
oe
1 10 10 1
11 2 3 4 5 6 7 8 9 20 20 9 8 7 6 5 4 3 2 11
12 13 14 15 16 17 18 19 19 18 17 16 15 14 13 12
lec
GD2
1 2 8 9 9 8 2 1
10 11 3 4 5 6 7 17 18 18 17 7 6 5 4 3 11 10
12 13 14 15 16 16 15 14 13 12
.ir
272
YARIS (EM01V0U)
K
HJ1 IJ1
na
5 4 3 2 1 5 4 3 2 1
1 2 3 4 5 1 2 3 4 5
9 8 7 6 9 8 7 6
6 7 8 9 6 7 8 9
1716151413121110 1716151413121110
1011121314151617 1011121314151617
JD1
sic
1 2 8 9 9 8 2 1
10 11 3 4 5 6 7 17 18 18 17 7 6 5 4 3 11 10
12 13 14 15 16 16 15 14 13 12
JD2
oe
1 10 10 1
11 2 3 4 5 6 7 8 9 20 20 9 8 7 6 5 4 3 2 11
12 13 14 15 16 17 18 19 19 18 17 16 15 14 13 12
lec
JD3 JX1 JY1
Yellow Yellow
2 1 2 1
1 2 3 4 5 6 7 8 9 10 10 9 8 7 6 5 4 3 2 1 1 2 1 2
11 1213141516171819 20 20 1918171615141312 11
.ir
273
YARIS (EM01V0U)
K CONNECTOR LIST
LJ1 MJ1
na
1 2 3 4 5 5 4 3 2 1 5 4 3 2 1
1 2 3 4 5
6 7 8 9 10 10 9 8 7 6
9 8 7 6
6 7 8 9
1716151413121110
1011121314151617
MN1 ZJ1 aJ1

sic
5 4 3 2 1 1 2 2 1 1 2 2 1
1 2 3 4 5
9 8 7 6
6 7 8 9
1716151413121110
1011121314151617
oe
lec
.ir
274
YARIS (EM01V0U)
Memo
na
sic
oe
lec
.ir
275
YARIS (EM01V0U)
A1 Turn Signal Lamp (Front Side RH) C2 Crankshaft Position Sensor 90980–12028
90980–11162
A2 Turn Signal Lamp (Front Side LH) C3 VSV (Purge) 90980–11156
A3 A/C Pressure Sensor 90980–10845 C4 Fuel Injector (No.1)
na
A4 Rear Washer Motor 90980–11051 C5 Fuel Injector (No.2)
90980–11875
A5 Windshield Washer Motor 90980–11019 C6 Fuel Injector (No.3)
A6 Airbag Sensor (Front RH) 90980–12490 C7 Fuel Injector (No.4)
A7 Speed Sensor (Front RH) 90980–11003 C8 A/C Compressor 90980–11156
A8 Cooling Fan Motor 90980–10928 C9 Generator 90980–11964
A9 Windshield Wiper Motor 90980–11599 C10 Generator 90980–09373
A10 Brake Fluid Level Warning SW 90980–11207 C11 Ignition Coil (No.1)
A11 Speed Sensor (Front LH) 90980–11003 C12 Ignition Coil (No.2)
90980–11885
A12 Airbag Sensor (Front LH) 90980–12490 C13 Ignition Coil (No.3)
A13 Stop Lamp SW 90980–11118 C14 Ignition Coil (No.4)
sic
A14 Radiator Fan Resistor 90980–10928 C15 Starter 90980–11400
A15 Skid Control ECU with Actuator 90980–12020 C16 Engine Oil Pressure SW 90980–11363
A16 Clutch Start SW 90980–10825 C17 Throttle Body Assembly 90980–11858
A17 PTC Heater 90980–10956 C18 Camshaft Position Sensor 90980–10947
A18 Engine Hood Courtesy SW 90980–11003 C19 Engine Coolant Temp. Sensor 90980–10735
A19 Power Steering ECU 90980–12300 C20 Engine Control Module 90980–12399
A20 Accelerator Position Sensor 90980–12303 C21 Speed Sensor 90980–11143
A21 Engine Control Module 90980–12462 C22 Back–Up Lamp SW 90980–11051
A22 Water Level Warning SW 90980–11068 C23 Air Fuel Ratio Sensor (Bank 1 Sensor 1) 90980–10869
A23 Security Horn 90980–11235 C24 Camshaft Timing Oil Control Valve 90980–11162
oe
A24 Junction Connector 90980–11661 C25 Noise Filter 90980–10843
A25 Junction Connector 90980–11915 C26 Mass Air Flow Meter 90980–11317
A26 Junction Connector 90980–11398 C27 Park/Neutral Position SW 90980–12362
A27 Fusible Link Block 90980–11996 Electronically Controlled Transmission
C28 90980–11658
Solenoid
A28 Fusible Link Block 90980–11775
C29 Speed Sensor (Turbine) 90980–11156
A29 Cruise Control Clutch SW 90980–10906
C30 Fusible Link Block 90980–09223
B1 Turn Signal Lamp (Front RH) 82824–52130
D1 Combination Meter 90980–12200
B2 Horn 90980–10619
B3 Parking Lamp (RH) 90080–98298
lec
D3 Spiral Cable 90980–12183
B4 Headlamp (RH) 90980–11314
D4 Headlamp Dimmer SW Assembly 90980–12007
B5 Ambient Temp. Sensor 90980–11070
D5 Windshield Wiper SW Assembly 90980–12358
B6 Headlamp (LH) 90980–11314
D6 Windshield Wiper SW Assembly 90980–12359
B7 Parking Lamp (LH) 90080–98298
D7 Hazard Warning Signal SW 82824–21030
B8 Turn Signal Lamp (Front LH) 82824–52130
D8 Ignition SW 90980–11615
B9 Fog Lamp (Front RH)
82824–60460 D9 Running Light Relay 90980–12034
B10 Fog Lamp (Front LH)
D10 Radio Receiver Assembly 90980–10997
B11 Side Marker Lamp (Front RH)
90980–11156 D11 Radio Receiver Assembly 90980–10996
B12 Side Marker Lamp (Front LH)
D12 Outer Mirror SW 90980–11657
B13 Junction Connector 90980–11661
D13 Key Interlock Solenoid 90980–12063
Turn Signal, Side Marker and Parking Lamp
.ir
B14
(RH) D14 Cigarette Lighter or Power Outlet 90980–12498
90980–10942
Turn Signal, Side Marker and Parking Lamp D15 Data Link Connector 3 90980–11978
B15
(LH)
D16 Airbag Sensor Assembly Center 90980–12391
C1 Starter 90980–09640
Note: Not all of the above part numbers of the connector are established for the supply.
276
PRIUS (EM01V0U)
L
D18 Spiral Cable 90980–12160 F6 Speaker (Front Door RH) 90980–10935
D19 Unlock Warning SW Door Lock Control SW (Front Passenger’s
90980–12063 F7 90980–11013
Side)
D20 A/T Shift Lever Illumination
G1 Power Window Master SW 90980–12122
na
D21 Parking Brake SW 90980–10871
G2 Outer Rear View Mirror (LH) 90980–12189
D22 Shift Lock Control ECU 90980–12183
G4 Power Window Regulator Motor (Front LH) 90980–10797
D23 Transponder Key ECU 90980–12423
G5 Door Lock Assembly (Driver’s Side) 90980–12226
D24 Transponder Key Amplifier 90980–12092
G6 Speaker (Front Door LH) 90980–10935
D25 Security Indicator Lamp 90980–12056
G7 Door Lock Control SW (Driver’s Side) 90980–11013
D26 Theft Warning ECU 90980–12564
H1 Power Window SW (Rear RH) 90980–10631
D27 Passenger Seat Belt Warning Lamp 90980–12012
H2 Power Window Regulator Motor (Rear RH) 90980–10797
D28 Oxygen Sensor (Bank 1 Sensor 2) 90980–11028
H3 Door Lock Assembly (Rear RH) 90980–12226
D29 Light Control Rheostat 90980–12361
H4 Speaker (Rear RH) 90980–10935
D30 Door Lock Control SW 90980–12550
sic
I1 Power Window SW (Rear LH) 90980–10631
D31 Power Steering ECU 90980–12290
I2 Power Window Regulator Motor (Rear LH) 90980–10797
D32 Antenna Amplifier 90980–10871
I3 Door Lock Assembly (Rear LH) 90980–12226
D33 Main Body ECU 90980–12203
I4 Speaker (Rear LH) 90980–10935
D34 Junction Connector
J1 Door Courtesy SW (Front RH)
D35 Junction Connector 82824–52010
J2 Door Courtesy SW (Front LH)
90980–12372 J3 Rear Combination Lamp (RH)
J4 Rear Combination Lamp (LH)
J5 Fuel Suction Pump and Gage Assembly 90980–11077
J8 Airbag Sensor Assembly Center 90980–12449
oe
J9 Airbag Sensor Assembly Center 90980–12450
90980–11915 J10 Front Seat Inner Belt (Driver’s Side)
J11 Front Seat Inner Belt Assembly (Front RH)
D43 Fuse Block 82610–52010
J12 Room Lamp (Luggage) 90980–11148
D44 Diode (Starter) 90980–10962
J13 Door Control Receiver 90980–12366
D45 ACC Cut Relay 82660–52040
J14 Airbag Sensor (Rear RH)
D46 Front Fog Light Relay 82660–52030 90980–12352
J15 Airbag Sensor (Rear LH)
D74 Radio Receiver Assembly 90980–12259
J16 Side Airbag Sensor (RH)
D75 Stereo Jack Adapter 82824–21030 90980–12225
J17 Side Airbag Sensor (LH)
lec
J20 Pretensioner (RH)
D77 Hazard Warning Signal SW 90980–12423 90980–12253
J21 Pretensioner (LH)
E1 Blower SW 90980–10993
J22 Curtain Shield Airbag Squib (RH)
E2 A/C Thermistor No.1 90980–11918 90980–12575
J23 Curtain Shield Airbag Squib (LH)
E3 Blower Resistor 90980–11136
J24 Occupant Classification ECU 90980–12356
E4 Blower Motor 90980–10916
J25 Canister Pump Module 90980–12380
E5 A/C SW 90980–12550
J26 Speaker (Rear RH)
E6 Rear Window Defogger SW 90980–12217 90980–10935
J27 Speaker (Rear LH)
E8 A/C Amplifier 90980–12155
J28 Junction Connector
E9 A/C Amplifier 90980–12200 90980–11661
J29 Junction Connector
E10 Junction Connector 90980–11915
J30 Diode (Room Lamp) 90980–10962
F1 Power Window SW (Front RH) 90980–10789
.ir
J31 Noise Filter 90980–10916
F2 Outer Rear View Mirror (RH) 90980–12189
J32 Door Courtesy SW (Rear RH)
F4 Power Window Regulator Motor (Front RH) 90980–10797 82824–52010
J33 Door Courtesy SW (Rear LH)
Door Lock Assembly (Front Passenger’s
F5 90980–12226
Side)
277
PRIUS (EM01V0U)
J34 Rear Combination Lamp (RH) Airbag Squib (Front Passenger’s Airbag
82824–52050 Q2 90980–12575
Assembly)
J35 Rear Combination Lamp (LH)
U1 Occupant Classification ECU 90980–12357
J36 License Plate Lamp (RH)
90980–11148 U2 Occupant Classification Sensor (Front LH)
na
J37 License Plate Lamp (LH)
U3 Occupant Classification Sensor (Rear LH)
J38 Speaker (Rear RH) 90980–12353
90980–11299 U4 Occupant Classification Sensor (Front RH)
J39 Speaker (Rear LH)
U5 Occupant Classification Sensor (Rear RH)
J40 High Mounted Stop Light 90980–11148
Cruise Control SW (S/D) 90980–12360
J41 High Mounted Stop Light 90980–11967
Spiral Cable (H/B) 90980–12361
J42 Door Lock Assembly (Luggage) 90980–10908
V1 Spiral Cable (S/D) 90980–12360
J43 Door Lock Assembly (Luggage) 90980–11212
Steering Pad SW (H/B) 90980–12361
J44 Rear Window Defogger 90980–10913
Steering Pad SW (S/D) 90980–12360
J45 Noise Filter 90980–10916
Airbag Squib (Steering Wheel Pad)
K1 Map Lamp 90980–11212
sic
W1 90980–12224
Spiral Cable
K2 Room Lamp (Center) –
Airbag Squib (Steering Wheel Pad)
L1 License Plate Lamp 90980–11162 W2 90980–12219
Spiral Cable
M1 Center Stop Lamp 90980–10860
X1 Side Airbag Squib (RH)
M2 Rear Window Defogger 90980–11853 90980–12452
Y1 Side Airbag Squib (LH)
N1 Rear Wiper Motor Assembly 90980–10860
Z1 Speed Sensor (Rear RH)
N2 Back Door Courtesy SW 90980–10795 90980–12416
a1 Speed Sensor (Rear LH)
N3 Back Door Lock Assembly 90980–10825
Power Steering ECU
N4 Back Door Position SW 90980–11150 b1 90980–12299
Rear Window Defogger (H/B) 90980–11853
O1 Power Steering ECU
Rear Window Defogger (S/D) 90980–10914 c1 90980–12221
oe
P1 Knock Control Sensor (Bank 1) 90980–11875
Airbag Squib (Front Passenger’s Airbag
Q1 90980–12576
Assembly)
lec
.ir
Note: Not all of the above part numbers of the connector are established for the supply.
278
PRIUS (EM01V0U)
Memo
na
sic
oe
lec
.ir
279
YARIS (EM01V0U)
280
M OVERALL ELECTRICAL WIRING DIAGRAM

* The system shown here is an EXAMPLE ONLY. It is different to the
HOW TO READ THIS SECTION
na
actual circuit shown in the wiring diagram section.
[A]
S ta rtin g E n g in e C o n tro l
1 2 3 4
B- R B- R
B- R
ACC
2
[M]
B- W
W 4 AM1 IG1 A11
sic
1 (BAT) Heated Oxygen Sensor
ST1 1 B- W
7. 5A 15A
IGN EFI
8 AM2 IG2 7 B- R [L]
2 2
ST2 2 B- L
2 3 1
2 2
W- R
(2L- T)
GR
[B] A
B
R- Y
B- W
A6
Ignition SW R- Y R- Y
B- L B
YARIS (EM01V0U)
R- Y
B
C
[E] 1 1
B- R
3 4
(2L- T) [H]
W EFI MAIN
B- L
(Shielded)
[J]
oe
(2L- T) [C] 7 BA3 Relay 12 BA1
Y- R
B
W- R
1 2
W
1 A 1 B
B- R
2 2 A40(A), A41(B) [I] 1 1
Starter
(22R- E)
B- W
Y- R
W- B
Relay B- W 21
Y- R Y- R Y- R
2 2 BA3 D
2 A 2 B
Y- R
Y- R
(2L- T)
(2L- T)
W- B
B- W
2 3 7 3C
B- W
Circuit Opening
100A ALT
40A AM1
30A AM2
[F]
(22R- E)
8 4

6 AB3
B- W
Relay
A19
[G] 1 6 15 3C
+B OX1
Emission ECU
B- W
lec R- G
B- R
1
< 9- 8>
(2L- T)
B- R B- R B- R FP E1
B- W
B1
2 5 AD2 [D] 1 3
B- R
B- R
B- R
B- R
W- B
R- G
R- G
1 A
2 2 2 2
R- G
Injection No. 1
Injection No. 2
Injection No. 3
Injection No. 4
B
16 AD1
B 1
B M
B11
B10
B12
17 BA3
R- G
B9
1 1 1 1
B38(A), B39(B)
BR
BR
Starter
W- R
W- R
W- R
W- R
R- G
2
Fuel Pump
M
A37
Battery W- R W- R W- R W- R
E
1 W- R W- R
F
W- B
W- B
A1
[K]
A1 A3
.ir B1
[A] : System Title [F] : Junction Block (The number in the circle is the J/B No.
and the connector code is shown beside it).
[B] : Indicates the wiring color.
na
Junction Blocks are shaded to clearly separate them
Wire colors are indicated by an alphabetical code. from other parts.
B = Black W = White BR = Brown
L = Blue V = Violet SB = Sky Blue Example:
R = Red G = Green LG = Light Green
3C indicates that
P = Pink Y = Yellow GR = Gray it is inside
Junction Block
O = Orange No.3
The first letter indicates the basic wire color and the
sic
second letter indicates the color of the stripe.
Example: L–Y
[G] : Indicates related system.

[H] : Indicates the wiring harness and wiring harness
YARIS (EM01V0U)
connector. The wiring harness with male

L Y terminal is shown with arrows ( ).
(Blue) (Yellow) Outside numerals are pin numbers.
[C] : The position of the parts is the same as shown in
the wiring diagram and wire routing.
oe
[D] : Indicates the pin number of the connector.
The numbering system is different for female and
male connectors.
Example: Numbered in other Numbered in other Female Male ( )
from upper left to from upper right to
lower right lower left [I] : ( ) is used to indicate different wiring and
connector, etc. when the vehicle model, engine type,
or specification is different.
[J] : Indicates a shielded cable.
Female Male
lec
The numbering system for the overall wiring diagram is
the same as above
[E] : Indicates a Relay Block. No shading is used and
only the Relay Block No. is shown to distinguish
it from the J/B.
Example: Indicates Relay Block No.1
[K] : Indicates a ground point.
[L] : The same code occurring on the next page indicates
that the wire harness is continuous.
[M] : Indicates the ignition key position(s) when the power is
supplied to the fuse(s).
.ir
281
M
282

SYSTEM INDEX
na
SYSTEMS LOCATION SYSTEMS LOCATION
ABS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17–1 Illumination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12–1
Air Conditioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29–1 Interior Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11–1
Audio System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26–1 Key Reminder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16–1
sic
Back–Up Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13–1 Light Reminder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16–1
Charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3–1 Multiplex Communication System (CAN) . . . . . . . . . . . . . . . . . . . . . . . 8–1
Cigarette Lighter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24–3 Power Outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24–3
Combination Meter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27–1 Power Source . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1–1

YARIS (EM01V0U)
Cooling Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28–1 Power Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20–1
oe
Cruise Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5–16 Rear Window Defogger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25–1
Data Link Connector 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7–1 Rear Wiper and Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23–1
Door Lock Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21–1 Remote Control Mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24–1
Electronically Controlled Transmission and A/T Indicator . . . . . . . . 5–17 Seat Belt Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18–7
Engine Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5–1 Shift Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23–3
lec
Engine Immobiliser System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6–1
EPS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19–1
Front Fog Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15–1
Front Wiper and Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22–1

SRS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18–1
Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2–1
Stop Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14–1
Taillight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12–1
Headlight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9–1 Theft Deterrent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21–10
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25–3
Ignition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4–1
.ir
Turn Signal and Hazard Warning Light . . . . . . . . . . . . . . . . . . . . . . . . 10–1
Wireless Door Lock Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21–9

1 YARIS (Cont. next page)
284

na
P o w e r S o u rc e
1 2 3 4
B
A
EFI Relay
40A HTR SUB2 30A ABS2/VSC2
1 20A EFI 10A EFI2
B 1 2 1 2
1E 4 4
1 2 B B 1 2
1A AA1 1
50A EPS 30A HTR SUB1
sic
10A HORN
1 2 1 2
1 2
50A ABS1/VSC1 30A RDI

15A AM2
1 2 1 2
1
W 1 2
1C
40A HTR
Y
1 2 B
YARIS (EM01V0U)
ACC 2 W
C
Y 4 AM1 IG1 1 G
D
IG2 Relay
oe
W
7. 5A ALT–S
Charging System
1
1 2 GR 5 AM2 IG2 6 P
1D
3 1B 2 1B 4 1B 1 1B
ST2 7
< 3–1>
15A DOME
1 2 D8
1
Ignition SW
GR
W
P
W
B
30A ST
Starting System
1 2 14 AA2
1 C 1 A 1 B 2 B
< 2–3>
7. 5A ECU–B
lec W–B
P
L
1 2
A27(B), A28(A), C30(C)
60A MAIN
120A ALT
Fusible Link Block
10A ETCS 5 AD4 3 AD2 4 AD2
1 2
GR
W
P
10A HAZ
1 2 W
E
Battery 1 2 L
F
10A H–LP RH/H–LP LO RH
1 2
A1
.ir
1 YARIS (Cont' d)
na
P o w e r S o u rc e
5 6 7 8
T–LP Relay
1 (∗1) (∗1) (∗1) 10A TAIL
B B
A 4G ∗ 1 : H/B, S/D ∗3
∗ 2 : Except ∗1
(∗1) (∗1) (∗1) 7. 5A PANEL1 ∗ 3 : Cold Area Spec. ,
w/ ABS,
30A DEF w/ Door Lock Control,
DEF Relay
1 2 10A ID/UP/MIR HTR w/ Daytime Running Light,
w/ Air Conditioning
sic
15A FR FOG
7. 5A OBD2
25A D/L
1
Y Y
B 4F
(∗2) 10A TAIL (∗2) 4
W
4M
(∗2)
YARIS (EM01V0U)
10A STOP 13
30A POWER
W PWR Relay
C B1

1 2
3
G G
D 4F B1 T1
25A AM1 Light OFF
oe
20A RL DOOR Control
SW Tail
Noise Filter
20A RR DOOR Head
1 7. 5A ACC2 2 B
D4
T1
10
D43 IG 1 Relay
10A ECU–IG
W
W
P
Fuse Block 5 3 G
(∗2)
2 1 25A WIP
8 4S 2 3
ACC Cut Relay
15A WSH 10 7. 5A PANEL2 7. 5A PANEL1

4E
15A CIG
D45
10A GAUGE
13 4B 1 4
L
5
4F
lec 7. 5A ACC
15A RR WIP
G
L
7. 5A A/C
7. 5A IGN
18 AD4
4 7. 5A MET
W W
E 4F
17 4E 7 4M
G
L
W–B
W–B
F
Engine Control
Module< 5–7>
1 6A
D1
.ir D2
285
M
2 YARIS
286

na
S ta rtin g ∗ 1 : A/T
∗ 2 : M/T
1 2 3 4
(BAT) (BAT)
30A 15A
ST AM2
5 AM2 IG2 B
2 2
ST2 7 B
1 1 1B
sic
D8
GR
Ignition SW
W
1 4 AD2 9 AD4
B
5 2 14 A 1
A21(A), C20(B)
STSW D44
ST Diode (Starter)
Relay
GR STA STAR
YARIS (EM01V0U)
2
3 1 48 A 52 B
SB
O
1 1 1
oe
8 CA1
W–B
V
B
15
A25
Junction Connector
BR
O
13 14 12
12 AA2
(∗2)
(∗1)
BR
W
B
O
10 CA1 9 CA1 5 AA2 1 AD4
O
(∗1)
W
lec
V
7 5
1 D36
Clutch Start SW
Junction Connector
1 B
1
A 6
5
A16
GR
B L C27
2 Park/Neutral
M P Position SW
W–B
(∗2)
B
10 AD4
N
C1(A), C15(B)
Starter 4
Y
(∗1)
GR
10 CA2 13 AA2
Battery
GR 2 1 Y
AI
(∗1)
Y
(∗2)
3 A25
Junction Connector
.ir
3 YARIS
na
C h a rg in g
1 2 3 4
(BAT) (IG) (IG)
∗ 1 : w/ Daytime Running Light 7. 5A 7. 5A 10A

∗ 2 : w/o Daytime Running Light ALT–S MET GAUGE
1 1 4M 19 4B
sic
B
Running Light
Relay< 9–7>
1 A
D1(A), D2(B), D76(C)

W
G
Combination Meter
Charge
(∗1)
G
Junction Connector
YARIS (EM01V0U)
A/C Amplifier< 29–6>

5 CA1 1 B (H/B) 1 CA1
1 C (S/D)
Module< 5–15>
Engine Control
13
14 SB(∗1)
D39
(∗2)
L
12
L(∗1)
oe
15 AD3
L
W
G
P
P
7 AA2
L
B
4 CA1
P
1
L
Fusible Link Block
120A ALT
1 B 3 A 1 A 4 A 2 A
C9(A), C10(B)
B
lec M S L IG Generator
C30
Battery
IC Regulator
.ir
287
M
4 YARIS
288

na
Ig n itio n
1 2 3 4
(BAT)
GR
D8 15A
AM2
Ignition SW
5 AM2 IG2 6 P
sic
ST2
5 AD4 4 AD2
R
P
14 AA2 11 CA1
YARIS (EM01V0U)
R
GR
R
P
oe
LG
2 1B 1 1B 4 1B
BR
LG
R
R
C11 C12 C13 C14
1 Ignition Coil (No. 1) 1 Ignition Coil (No. 2) 1 Ignition Coil (No. 3) 1 Ignition Coil (No. 4) 1
Noise Filter
+B +B +B +B
IG2
C25
Relay
GND IGT IGF IGF IGT2 GND IGF GND IGT3 IGF GND IGT4
4 3 2 2 3 4 2 4 3 2 4 3
3 1B
W–B
W–B
W–B
W–B
W–B
LG
W
G
Y
L
lec Y
W–B
Y
W–B
W–B
AI CI
.ir < 5–11>
Memo
na
sic
oe
lec
.ir
YARIS (EM01V0U)
289
290

na
E n g in e C o n tro l
1 2 3 4
(BAT) (BAT) (IG)
20A 15A 7. 5A
EFI AM2 IGN
2 2
sic
C/OPN
EFI IG2 5 AM2 IG2 6 Relay
Relay Relay
ST2
D8 27 4B 9 4B 5 4E 11 4B 8 4A
1 1A 4 1A 3 1A 2 1A 3 1B 2 1B 4 1B 1 1B Ignition SW
W–B
W–B
GR
GR
GR
R
R
Y
B
YARIS (EM01V0U)
P
A
14 AA2 4 AD2 5 AD4
11 CA1
oe
P
Fuel Suction Pump and

4
Gage Assembly
Pump
M
R
J5
5
BR
LG
R

1 1 1 1
W–B
V
B
lec
C4
C5
C6
C7
R
2 2 2 2 C
L L
GR
SB
D
P
P
E
GR
F
SB
G
GR
H
B B B
I
Y
J
W–B
W–B
W–B
A1
.ir J1
5 YARIS (Cont' d) (Cont. next page)
na
5 6 7 8
(BAT) (BAT)
10A 10A
STOP ETCS
18 4B 1

P
sic
P
Starting System< 2–3>

1
GR
3 2
Stop Lamp SW< 14–2>
ACC Cut Relay< 1–5>

A13
TAIL Fuse< 12–3>

Light Control SW
Stop Lamp SW
C19
< 12–3>
4 1 2 24 AA2
YARIS (EM01V0U)
System< 14–2>
P
Stop Light
GR
G
G
Y
L
A21(A), C20(B)
Engine Control Module 35 A 36 A 14 A 52 B 48 A 13 A 96 B 97 B 3 A 31 A
oe
ST1– STP STSW STAR STA ACCR ETHW THW +BM ELS
FC IGSW # 40 # 30 # 20 # 10 MREL BATT +B2 VPMP VCPP PPMP EPPM MPMP +B IMI IMO EOM PRG
7 A 28 A 105 B 106 B 107 B 108 B 44 A 20 A 1 A 42 A 70 B 71 B 94 B 34 A 2 A 11 A 10 A 9 A 49 B
O
V
BR
W
O
GR
GR
SB
R
V
B
L
15 CA2 16 CA2 17 CA2 14 CA2
L
12 AD4 1
BR
O
B
V
L
2
1
Transponder Key ECU< 6–2>

6 AA1 10 AA1 9 AA1 3 AA1 5 AA1
VSV (Purge)
V 10A
B EFI2
BR
BR
O
B
B
L
R
C3
C
E
L
lec1
1
4 AJ1 1 AJ1 7 AJ1 6 AJ1 5 AJ1 2 AJ1 3 AJ1
2
BR
O
V
V
L
GR
F
B
9 8 4 3 2 1 6
SB
G VLVB VGND VCC VOUT SGND MTRB MGND
V
GR
H
Canister Pump Module
4
B B B
I AA1
Y
J
M
Canister Pressure Sensor
B
J25
Vent Valve Leak Detection Pump
1 12
B V V V B
AA2 CA1 A
.ir C2
B
9
B
5
B
291
AA2 AD5 B
M
292

na
9 10 11 12
sic
C17
FAN NO. 1 Relay< 28–2>
FAN NO. 2 Relay< 28–3>

< 4–2> < 4–3> < 4–4>
Ignition Coils
3 5 6 4 2 1
YARIS (EM01V0U)
(Shielded)
GR
W
R
V
LG
LG
W
O
G
Y
BR
A21(A), C20(B)
oe
91 B 67 B 115 B 114 B 42 B 41 B 63 B Engine Control Module 85 B 84 B 83 B 82 B 81 B 21 A 22 A
ETA VCTA VTA1 VTA2 M+ M– GE01 IGT1 IGT2 IGT3 IGT4 IGF1 FAN FAN2
THA E2G VG ETHA HA1A A1A– A1A+ HT1B EX1B OX1B KNK1 EKNK NE+ NE– G2+
65 B 116 B 118 B 88 B 109 B 113 B 112 B 47 B 87 B 64 B 110 B 111 B 122 B 121 B 99 B
(Shielded)
(Shielded)
P
GR
LG
G
R
5 CA2 4 CA2 2 CA2 3 CA2 1 CP1 2 CP1
(Shielded)
(Shielded)
(Shielded)
GR
LG
LG
W
O
G
P
B
L
(Shielded)
lec
GR
LG
B
Knock Control Sensor
4 2 3 5 1 4 3 2
Crankshaft Position
Camshaft Position
THA E2G VG E2 HA1A A1A– A1A+ 4 AD5 3 AD5 1 AD5 2 AD5 1 2
Oxygen Sensor (Bank 1 Sensor 2)
(Bank 1)
Sensor
Sensor
+B +B
(Shielded)
GR
LG
C18
C2
C26 C23
P1
1 2
W
Mass Air Flow Meter Air Fuel Ratio Sensor 2 1

(Bank 1 Sensor 1) 1 4
1
HT1B E2
B
D28
+B OX1B
2 3
W
B
B B
.ir
BR
A
C1
B B
B
na
E n g in e C o n tro l C ru is e C o n tro l
13 14 15 16
(BAT)
30A
DEF
2
11 4M
A20
Speed Sensor (Turbine)
sic
1 DEF
Relay
10A
ID/UP/
MIR HTR
C29

2 1 3 2 4 6 5
V
8 AD3
YARIS (EM01V0U)
BR
W
G
R
B
L
(A/T)
(A/T)
G
B
V
A21(A), C20(B)
125 B 124 B Engine Control Module 33 A 58 A 56 A 60 A 57 A 55 A 59 A
oe
NT+ NT– ELS3 VCP2 VPA2 EPA2 VCPA VPA EPA
OC1+ OC1– EC E1 ME01 E01 E04 E03 SPD TC TACH ALT E02 CANL CANH CCS
100 B 123 B 32 A 104 B 43 B 45 B 46 B 86 B 8 A 27 A 15 A 50 B 44 B 49 A 41 A 40 A
W–B
W–B
(∗1)
LG
V
L
6 AD4
Combination Meter< 27–3>
Generator< 3–2>
Multiplex Communication
Data Link Connector 3< 7–3>
(∗1)
L
BR
System (CAN)< 8–3>

W–B
W–B
Camshaft Timing Oil Control Valve
BR
BR
BR
W
R
lec 7
6
D34
Junction
(∗1)
Connector 2 A
4 B
ECC
D3(A), V1(B)
Spiral
Cable 1 A
3 B
CCS
(∗1)
BR
MAIN
C24
2 6 AD2
+RES
(∗1)
BR
–SET
13 CA1
(∗1)
BR
CANCEL
A1 C2
.ir C1 C1
V1(B)
293
Cruise Control SW
M
5 YARIS (Cont' d)
294

na
E le c tro n ic a lly C o n tro lle d T ra n s m is s io n a n d A /T In d ic a to r ∗ 2 : S/D M/T w/ Cruise Control
∗ 3 : S/D A/T
17 18 19 20
(IG) (IG) (IG) (BAT)
G
(A/T)
10A 10A 7. 5A 7. 5A
GAUGE ECU–IG MET ECU–B
1 CA1 2
19 4B 24 4B
2
sic
1 4M 30 4B 1
(∗2)
RB
B
G
L
(A/T) 16
A25
Junction
Connector 2 4S
C27
PL RL NL DL 2L LL 25 AA2
21
B
Park/Neutral Position
(∗2)
6 1 9 7 3 8
B
L 1
Cruise Control
L
SW< 13–2>
(A/T)
Clutch SW
A29
YARIS (EM01V0U)
System< 13–1>
Back–Up Light
1 A 2 A
(A/T)
(A/T)
(A/T)
(A/T)
2
(A/T, ∗2)
SB
G
R
L
14 CA1
(A/T)
(∗2)
R
L
A21(A), C20(B)
(∗3)
(∗3)
(∗3)
(∗3)
(∗3)
(∗3)
oe
53 B 73 B 54 B 55 B 74 B Engine Control Module 56 B
(A/T)
R P N 2 L D
CRUISE
D
P
L
S1 S2 SLU+ SLU– SLT+ SLT– ST THO1 ETHO W ODMS 5V IC
22 AA2
(∗3)
(∗3)
(∗3)
(∗3)
(∗3)
(∗3)
79 B 78 B 57 B 77 B 76 B 75 B 80 B 72 B 95 B 24 A 26 A
(A/T)
L
LED Driver
Indicator Lamp
(A/T)
O
B
2 AD3
Malfunction
CPU
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
(A/T)
GR
SB
CAN Controller
W
O
G
P
B
L

17 AD3 14 AD3
Speedometer
9
Tachometer
5 10 4 9 3 8 2 1 6
lec NSSD
Transmission
Control SW
CAN I/F
B
D22
AT3
S1 S2 SLU+(H/B) SLU– SLT+ SLT– ST THO E2
SL(S/D) 3
GR
BR
LG
W
O
G
B
O
(A/T)
4 B (H/B) 20 A 21 A 24 A D1(A), D2(B), D76(C)
4 C (S/D) Combination Meter
BR
B
C28
Electronically
Solenoid
Multiplex
Communication
.ir D3
6 YARIS
na
E n g in e Im m o b ilis e r S y s te m
1 2 3 4
(BAT) (IG)
7. 5A 7. 5A
ECU–B IGN
1 21 4E
sic
L
D24
25 AA2 Transponder Key Amplifier
Transponder Key Coil
L
30 4B Engine Control Module< 5–8>
12 4H
R
YARIS (EM01V0U)
VC5 CODE TXCT AGND

P
1 4 5 7
BR
W
O
11 A
D36(A), D37(B)
Junction Connector
8 AD4 17 AD4 7 AD4
GR
G
P
V
2 B
oe
W
BR
L
1 2 13 12 11 14 15 4 5
+B IG EFIO EFII EGND VC5 CODE TXCT AGND
GND IND KSW CTY D

D23 16 8 3 7 9
Transponder Key ECU LG
W–B
W
O
B
(S/D)
17
D35
(H/B)
Junction
LG
Connector
16
LG
Door Courtesy SW

Unlock Warning SW< 16–4>
(Front LH)< 11–4>

(S/D)
2
lec W–B
11
5
W–B
D40
W–B
Junction Connector
6
D25
Security
Indicator Lamp
3 6A
D2
.ir
295
M
7 YARIS
296

na
D a ta L in k C o n n e c to r 3
1 2 3 4
(BAT)
Transponder Key ECU

Power Steering ECU

Classification ECU
7. 5A
OBD2
Occupant
< 18–9>
< 19–3>
< 6–3>
Airbag Sensor Assembly Center< 18–1>

5 4S
Engine Control Module< 5–15>

sic
Power Steering ECU< 19–3>

W
P
12 A 13 A
D34(A), D35(B)
Junction Connector
21 B 20 B
YARIS (EM01V0U)
SB
LG
LG
W
O
P
3 4S 31 4E 23 4B
oe
13 AD4
7 4E 12 4D
LG
P
L
16 7 13 9 12
BAT SIL TC TAC TS
CG SG CANH CANL
4
lec 5
BR
(∗1)
5 A
D15
6 14
W–B
D34(A)
Junction
Connector
6 A
(∗2)
BR
Multiplex
Communication
BR System (CAN)< 8–3>
(∗1)
6 AD2
BR
13 CA1
W–B
W–B
.ir
BR
D2 D1 C1
8 YARIS
na
M u ltip le x C o m m u n ic a tio n S y s te m (C A N )
1 2 3 4
D33 D31 D16

Main Body ECU Power Steering ECU Airbag Sensor Assembly Center
CANL CANH CANH CANL CANH CANL
sic
22 23 1 7 13 22
SB
W
W
R
B
YARIS (EM01V0U)
D41
16 5 4 15 11 22 22 11 8 19 Junction Connector
D42
Junction Connector
oe 7 18
W
15 4 3 14 6 17 1 12
W
G
G
V
V
L
16 AD4 15 AD4 1 DE1 10 DE1 11 AD4 2 AD4
lec W
W
G
V
L
20 21 49 41 6 14 2 3 6 5
CANH CANL CANL CANH CANH CANL TX+ TX– CANH CANL
D1 A21 D15 E8 A15

Combination Meter Engine Control Module Data Link Connector 3 A/C Amplifier Skid Control ECU with Actuator
.ir
297
M
298

na
H e a d lig h t
1 2 3 4
(BAT) (BAT) (BAT)
10A 10A 7. 5A ∗ 3 : w/ H–LP/AMT Relay
H–LP RH/ H–LP LH/
H–LP LO RH H–LP LO LH
ECU–B ∗ 4 : w/o H–LP/AMT Relay
2 2 2
1 1 1
sic
L
GR(∗4)
B
GR
GR(∗3) GR(∗3)
3 BA1 6 BA1
7
L(∗3) L L
GR
AD5
B
(∗1 ∗3) (∗1 ∗3)

3 3 GR(∗3)
25 AA2
B4 B6
Headlamp (RH) Headlamp (LH) 2 2
8 AA2
YARIS (EM01V0U)
L
2 1 2 1
GR
BR 30 4B 5 1
G
L 20 AD3 H–LP/AMT
G
Relay
2 4S
oe
GR
7 BA1 4 BA1 2 BA1 5 BA1 3 2
L
14 B (H/B)
V(∗4) 14 C (S/D) 2 A
BR
G
V(∗3)
2 2
L(∗4)
L(∗3)
W–B
(∗3)
(∗3)
34 4B 16 4B L(∗3) V(∗4)
V
D1(A), D2(B), D76(C)
GR(∗3)
Combination Meter
Head (USA)
Beam
17 4B
16 4C 4 4J
11 B 13 B (H/B)
11 C 13 C (S/D) 35 4B 3 4J
P
(∗4)
P P
Y
L
(∗1)
GR
(∗2)
lec (∗2)
P 6
L
(∗1) 7 LG
SB 7 5 A/C Amplifier< 29–6>
D39
Junction
9 8 Connector 8 LG
Main Body ECU< 21–7>
HU HL 6
SB 1 2 W Headlamp Dimmer SW
(∗2) Assembly< 15–1>
D40
Dimmer SW
Junction Connector
Control SW
OFF Flash
18 B
D37(B)
Light
(∗1)
Junction Connector
BR
Tail Low L
A
Head High
16 B 17 B (∗1 ∗3)
RF ED
(∗1)
P
L
D4 12 11
Headlamp Dimmer SW L P(∗1)
Assembly
W–B
12
4E
17
4E
W–B
D1
.ir AI
BR(∗1)
B
C
9 YARIS (Cont' d)
na
H e a d lig h t
5 6 7 8
(BAT) (IG) ∗ 1 : w/ Daytime Running Light
∗ 3 : w/ H–LP/AMT Relay
7. 5A 10A
ECU–B ECU–IG
L
Headlamp Dimmer SW Assembly< 15–1>

1 30 4B 7 4S
sic
L
R
12 4H
25 AA2
P
8 B
D37(B)
Junction Connector
Junction Connector
9 B
D36(A), D37(B)
11 A
YARIS (EM01V0U)
4 B
GR
O
R
oe
3 12 16
+B IG FOG
D9
Running Light Relay
DRL H HI E PKB CHG–

1 7
lec 8 2 11 9
(∗1 ∗3)
W–B
(∗1)
(∗1)
BR
LG
G
P
L
6 AD5
Parking Brake SW< 11–4>
Generator< 3–3>
L
A
(∗1 ∗3) W–B
P(∗1)
B
C
BR(∗1)
A1
.ir
299
M
300
YARIS (EM01V0U)
B14
Parking Lamp (RH)
2
1
W–B G
10 YARIS
(S/D) (S/D)
Turn
B1
Turn Signal Lamp A24(A), B13(B)
(Front RH) Junction Connector
2
1
2
1
W–B W–B G G
1
3 B
4 A
IG
B1
31 4B
LR
(IG)
(H/B) (H/B)
B15
10A
Turn Signal, Side Marker and G
3 A
W–B
GAUGE
Parking Lamp (LH) (H/B)
2
1
W–B LG
(S/D) (S/D)
Turn
B8
Turn Signal Lamp
(Front LH)
2
1
3
W–B LG LG
5 B
1 A
LL
14 4B
(H/B) (H/B) 4
2
R
1
32 4B
+B
(BAT)
LG
2 A
(H/B)
10A
HAZ
2
1
W–B W–B LG
A1
(H/B) (H/B) (H/B)
A2
Turn Signal Lamp (Front Side LH)
FLASH Relay
2
1
W–B G
(H/B) (H/B)
A1
2
Turn Signal Lamp (Front Side RH)

na
W–B Y
J1
28 4A
Turn
6 B (H/B)
6 A (S/D)
3 B (H/B)
2 A (S/D)
J3(B), J34(A)
sic
W–B LG
J2
27 4A
Turn
6 B (H/B)
6 A (S/D)
3 B (H/B)
2 A (S/D)
J4(B), J35(A)
T u rn S ig n a l a n d H a z a rd W a rn in g L ig h t
oe
Turn RH
3
BR
15 B
15 C
16 4S
Turn LH
BR LG
24 A
13 4S
D3
8 C (S/D)
8 B (H/B)
D1(A), D2(B), D76(C)

Combination Meter
lec
D4
< 21–3>
Turn
Signal SW
Assembly
Main Body ECU

LH
RH
Headlamp Dimmer SW
5
8
E
7
11
W–B W–B W–B B

E
3 6A
17 4S
D2
EHW
D40
1 B (H/B)
4 A (S/D)
4 B (H/B)
15 A (S/D)
.ir
6
6
TR
Junction V
TR
ER
Connector
W–B
Signal SW
5 6A
7
5
5
TL
B
D7(B), D77(A)
TL
EL
12 4S 11 4S
Hazard Warning
GND
4
W–B
1 6A
7 4M
W–B W–B
17 4E
28 4E
D1

Memo
na
sic
oe
lec
.ir
YARIS (EM01V0U)
301
302
YARIS (EM01V0U)
11 YARIS
K1
Map Lamp
1
2
L L L
5 4K
13 4B
(BAT)
2
W–B
15A
1
DOME
K2
Room Lamp (Center)
3
W–B
On
1
Off L
2
P
Door
2
1
GR GR L
10 A
1 B
4 4P
12 JD1
J12 D38(A), D39(B)
Room Lamp (Luggage) Junction
Connector
O
23
SB
6 B
7 4A
2
BCTY(H/B)
LGCY(S/D)
na
1
2
W
2 A
5 B
J30 J28(A), J29(B)

Diode (Room Lamp) Junction
Connector
BR(H/B)
BR(S/D)
Courtesy
1
2
W–B BR BR
N1
12 MJ1
15 MN1
(H/B) (H/B) (H/B)

sic
N2
Back Door
In te rio r L ig h t
Courtesy SW
Courtesy
2
3
W–B BR
J2
(S/D) (S/D)
J42
Door Lock
Assembly (Luggage)
7
P
2 4K
ILE
oe
3
W–B
1 4K
GND1
W–B W–B
17 4E
D1
D33(A)
lec
B
Main Body ECU

6 4C
1
26
R
21 4A
DCTY
J2
.ir
1
24
Y
4
2 4C
PKB
D21
Parking Brake SW
LG
Running Light Relay< 9–7>
5 4C
(Cont. next page)

11 YARIS (Cont' d)
na
In te rio r L ig h t
5 6 7 8
(ACC) (BAT) (BAT) (IG) ∗ 2 : S/D w/o Tachometer, H/B
∗ 3 : S/D ∗5
7. 5A 25A 7. 5A L 7. 5A ∗ 5 : Cold Area Spec. ,
ACC D/L ECU–B MET w/ Engine Immobiliser System,
w/ ABS,
2 w/ Door Lock Control,
1 1 4M
25 w/ Remote Control Mirror,
L L
AA2 w/ Air Conditioning
sic
B
30 4B 2 4S D1(A), D76(C)
2 A 1 A Combination Meter
(∗2)
21 4 6
D33(A)
(∗1)
(∗1)
(∗1)
(∗1)
ACC ALTB BECU Main Body ECU
(∗1)
(∗1)
PCTY RRCY CANH CANL
20 22 23 A 22 A
(Front RH)
(Rear RH)
(Front LH)
(Luggage)
(Rear LH)
Graphic
Door
Door
Door
Door
Door
Door
Door
YARIS (EM01V0U)
24 4A 20 4A 5 4A
(∗1)
(∗1)
(∗2)
(∗1)
(∗1)
(∗1)
(∗1)
LED Driver
oe
CPU
CAN Controller
(∗4)
(∗4)
(∗3)
G
Y
L
CAN I/F
22 C 20 C 21 C 21 A 20 A 24 A
1 1 1
(∗3)
(∗3)
(∗3)
G
Y
L
J32
J33
5 JD2 2 JD2 3 JD2
lec
J1
Y(∗3)
(∗3)
(∗3)
G
L
BR
G(∗3)
L(∗3)
.ir D3
303
M
304
YARIS (EM01V0U)
B14
Parking Lamp (RH) D4
1
4
G (BAT)
120A ALT
(S/D)
12 YARIS
Side
Marker A28
SW
Light
Fusible
Control
2
3
Link Block
W–B G
(S/D) (S/D)
Parking
Tail
OFF
Head
1
B1
13
W Main Body ECU
9 4S
B1
(∗1) < 21–3>
10
T1
W–B
T1
4 6A
D2
B
(∗1)
W
B15
4 4M
Turn Signal, Side Marker and (∗2)
Parking Lamp (LH)
G
10A
(∗2)
TAIL
4
G
(∗1)
(∗2)
(S/D)
Side (∗1)
1 4G
Marker
2
3
W–B G (∗1)
(S/D) (S/D)
w/ ABS,
∗ 2 : Except ∗1
Parking
∗ 1 : H/B, S/D ∗3
(∗1)
T–LP
Relay
w/ Air Conditioning
W–B
(S/D)

1
2
W–B G
9 B
(H/B) (H/B)
B11
Side Marker Lamp
(Front RH)
W–B
1
2
W–B W–B W–B G
10 B
10 A
A1
8 BA1
(H/B) (H/B)
2
B12
Side Marker Lamp
GR
na
(Front LH)
W–B
2
1
W–B W–B G
7 B
11 A
B1
(H/B) (H/B) G
10 4E
B3 (∗2)
Parking Lamp (RH)
2
1
W–B G P
8 B
12 A
33 4B
(H/B) (H/B)
B7 A24(A), B13(B)
Parking Lamp (LH) Junction Connector
10A
7. 5A
TAIL(∗1)
Tail
PANEL2(∗2)
W–B GR
sic
J1
10 4A
6 B (H/B)
6 A (S/D)
4 B (H/B)
4 A (S/D)
J3(B), J34(A)
G
T a illig h t a n d Illu m in a tio n

15 4B
Tail
W–B W–B G G
J2
29 4A
G
6 B (H/B)
6 A (S/D)
4 B (H/B)
4 A (S/D)
(S/D)
oe
J4(B), J35(A)
3
1
2
W–B W–B G G
9 LJ1
4 LJ1
(H/B) (H/B) (H/B) (H/B)

L1
1
2
License Plate Lamp W–B G

(S/D) (S/D)
J36
License Plate
Lamp (RH)
1
2
W–B W–B G
(S/D) (S/D) (S/D)
J37
License Plate
Tail (Canada) Lamp (LH)
lec
G
7 4P
16 C (S/D)
16 B (H/B)
7. 5A
Pointer
PANEL1
B
1 A
1 4M
(IG)
.ir
BR Dial
24 A
D3
MET
CPU
Illumination I/F
7. 5A
4
G R
14 A
2 4Q
6 4Q
Y
15 A
I/F
I/F
GR
7 A
G
D1(A), D2(B), D76(C)

5
10 4P
9 4Q
DE1
Combination Meter
Y
V
G
BR
GR
R(S/D)
R(H/B)
SB(H/B)
F
E
B
A
H
D
C
G
(Cont. next page)

305
YARIS (EM01V0U)
F
E
B
A
H
D
C
G
Y
V
G
BR
GR
R(S/D)
R(H/B)
SB(H/B)
1
2
11
19
20
LG L
E10
E1
Blower SW
E10
Junction Connector
4
5
10
21
W GR
12 YARIS (Cont' d)
Junction Connector
5
E6
Rear Window
Defogger SW
9
8
6
5
22
R W B
E5
A/C SW
8
DE1
3
13
W
R
(S/D)
D77
2
3
W W R
(H/B) (H/B)
D7
6
na
2
ILL–
7
ILL+
W SB
(H/B) (H/B)
D30
D38(A), D39(B)
Junction
Connector
R
LG
16 B
sic
GR
16 A
17 B
D20
A/T Shift Lever Illumination
1
2
W G
18 A
18 B
T a illig h t a n d Illu m in a tio n
Junction
Connector
8 B
D38(A), D39(B)
oe
7
G G V
5 B
10 A
2 A
9 B
ILL–
ILL+
D10(A), D11(B)
11 B
Passenger Seat Belt Warning Lamp B

< 18–7> (H/B)
lec
2
LG
RV
9
5
W O BR
T
20 B
15 A
RL
.ir
D36(A), D37(B)
D29
Junction Connector
8
Light Control Rheostat
8
10
Y SB
IG
1 4P
TC
(IG)
10A
3
GAUGE
W–B
E
2 6A
D2
M
13 YARIS
306

na
B a c k – U p L ig h t
1 2 3 4
(IG)
10A ∗ 1 : A/T
GAUGE ∗ 2 : M/T
19 4B
sic G
1 CA1
G
YARIS (EM01V0U)
(∗2)
(∗1)
G
2 2
C22
Back–Up Lamp SW RB RL
oe
J28(A), J29(B)
9 B Junction Connector
R
C27
1 1
10 A 9 A
(∗1)
R
R
(∗1)
(∗2)
R
BR
R
R
(∗1)
R

lec
30 4A
5 A (S/D)
1 B (H/B)
J3(B), J34(A)
5 A (S/D)
1 B (H/B)
J4(B), J35(A)
Back–Up
Back–Up
3 CA1 6 A (S/D) 6 A (S/D)
< 5–17>
22 4B 6 B (H/B) 6 B (H/B)
R
W–B
W–B
J1 J2
.ir
14 YARIS
na
S to p L ig h t ∗ 1 : S/D LED Type
∗ 2 : S/D Bulb Type
1 2 3 4
(BAT)
10A
STOP
18 4B
sic B
2
A13
Stop Lamp SW
1
G Engine Control
Module< 5–6> O
(S/D)
YARIS (EM01V0U)
G
12 4B O
(H/B)
(∗1)
(∗2)
21 18
O
Skid Control ECU G G Shift Lock 10 MJ1
4B 4S Control ECU
with Actuator< 17–2>
< 23–4>
oe
12 4A
(S/D)
(H/B)
O
O
2 A (∗1)
Center Stop Lamp
Center Stop Lamp

1 B (H/B) 1
M1(B), J41(A)
V
J28(A), J29(B)
3 B Junction Connector 4 B
J40
1 A (∗1)
2 B (H/B) 2
3 A 4 A
(H/B)
W–B
W–B
(∗2)
O
V

1 A (S/D)
5 B (H/B)
lec 1 A (S/D)
5 B (H/B)
J4(B), J35(A)
J3(B), J34(A)
Stop
Stop
6 A (S/D) 6 A (S/D)
6 B (H/B) 6 B (H/B)
11 MJ1
W–B
W–B
W–B(H/B)
W–B
(∗1)
W–B(S/D)
W–B
W–B
J2 J1
.ir
307
M
15 YARIS
308

na
F ro n t F o g L ig h t
1 2 3 4
(BAT)

FR FOG
9 4M
sic
V
D4
LFG BFG
V
Fog Light OFF
SW 2 5
D46
Front Front Fog Light Relay
YARIS (EM01V0U)
LFG BFG
4 3 1 3
Y R
oe
(∗2)
(∗1)
W
7 AD2
R
Headlamp Dimmer SW
Running Light Relay< 9–7>

Assembly< 9–4>
7 B (H/B) 6 A
A24(A), B13(B)
7 C (S/D) Junction Connector
2 B 1 B
Front
Fog
lec
(S/D)
D1(A), D2(B), D76(C)
R
Combination Meter
(H/B)
(S/D)
2 2
B10 B9
Fog Lamp (Front LH) Fog Lamp (Front RH)
24 A 1 1
W–B
W–B
W–B
BR
D3
.irB1
16 YARIS
na
K e y R e m in d e r a n d L ig h t R e m in d e r
1 2 3 4
(IG) (BAT)
7. 5A 7. 5A
MET ECU–B
1 4M 1
sic B
L
25 AA2
L
YARIS (EM01V0U)
System< 12–4>
Taillight and
Illumination
14
Illumination I/F
1
oe L
2
5V IC
D33(A)
Main Body ECU
CANL
22 A 23 A
CANH GND1
1
17 4E
2 4S
6
BECU
DCTY
26
21 4A
30 4B
KSW
9
7 4D 6 4E 4 4C
CPU
lec
W–B
CAN Controller
O
Y
Y
Unlock Warning SW
1

CAN I/F I/F
Interior Light System

Theft Warning ECU< 21–12>
Buzzer
D19
2
< 11–4>
20 21 24 D1
Combination Meter
W–B
BR
Multiplex 1 5A
Communication
D3
.ir D1
309
M
17 YARIS
310

na
ABS
1 2 3 4
(IG) (IG) (BAT) (BAT)
7. 5A 10A 30A 50A

MET ECU–IG ABS2/ ABS1/
VSC2 VSC1
2 2
1 4M 24 4B 1 1
sic
W
B
B
16
A25
B
Junction Connector
A11 A7
Speed Sensor (Front LH) Speed Sensor (Front RH)
19
2 1 2 1
8 AA1 7 AA1
1 A
B
YARIS (EM01V0U)
W
G
R
B
1 AA1
Brake (Canada)
BRAKE (USA)
ABS
oe
B
LED Driver 25 9 8 31 30 1 23
Speedometer
IG1 FL+ FL– FR+ FR– +BS +BM
A15
Skid Control ECU with Actuator
CPU STP CANL CANH RL– RL+ RR– RR+ GND1 GND2
D1(A), D2(B), D76(C)
Combination Meter
CAN Controller 10 5 6 12 11 34 33 2 24
LG
B
W–B
W–B
CAN I/F
G
2 B (H/B)
2 C (S/D)
24 A 21 A 20 A
lec Stop Lamp SW

< 14–1>
11 AJ1 10 AJ1 9 AJ1 8 AJ1
LG
B
L
Combination Meter
System< 27–5>

BR
Communication
2 aJ1 1 aJ1 2 ZJ1 1 ZJ1

Multiplex
BR
BR
W
W
1 2 1 2
W–B
a1 Z1
(Rear LH) (Rear RH)
D3
.ir A2
Memo
na
sic
oe
lec
.ir
YARIS (EM01V0U)
311
312

na
SRS
1 2 3 4
(IG)
7. 5A
IGN
16 4E
sic
J15 J14
Airbag Sensor (Rear LH) Airbag Sensor (Rear RH)
A6 A12
Airbag Sensor Airbag Sensor
(Front RH) (Front LH)
BCL+ BCL– BCR+ BCR–

2 1 2 1
+SR –SR +SL –SL
2 1 2 1
YARIS (EM01V0U)
R
B
B
1 2 1 2
1 AD1 2 AD1 3 AD1 4 AD1 BCL+ BCL– BCR+ BCR–
J17 J16
Side Airbag Sensor (LH) Side Airbag Sensor (RH)
oe
BBL+ BBL– BBR+ BBR–
4 3 4 3
W
R
B
L
D16(A), J8(C), J9(B)
16 A 21 A 29 A 27 A 30 A 28 A 8 C 15 C 8 B 11 B Airbag Sensor Assembly Center
SIL IG2 +SR –SR +SL –SL BBD+ BBD– BBP+ BBP–
E2 E1 PD+ PD– PP+ PP– P+ P– P2+ P2– SFP+ SFP– SFD+ SFD– ICP+ ICP– ICD+ ICD–
26 A 25 A 2 C 1 C 4 B 5 B 4 A 3 A 1 A 2 A 7 B 6 B 9 C 10 C 9 B 10 B 7 C 6 C
lec
W–B
W–B
Y–G
Y–R
Y–R
Y–B
Y–B
Y–B
Y–B
Y–B
Y–B
Y–B
Y
Y
14 4E 30 4E 1 DQ1 2 DQ1 3 DQ1 4 DQ1 2 JX1 1 JX1 2 JY1 1 JY1
Y–G
Y–R
Y–B
Y–B
Y–B
Y
Y
17 4E 2 1 2 1 2 A 1 A 2 B 1 B 2 1 2 1 1 2 1 2
J21 J20 Q1(A), Q2(B) X1 Y1 J22 J23

Pretensioner Pretensioner Airbag Squib Side Airbag Squib (RH) Side Airbag Squib (LH) Curtain Shield Airbag Curtain Shield
(LH) (RH) (Front Passenger' s Airbag Assembly) Squib (RH) Airbag Squib (LH)
W–B
D1
.ir
na
SRS S e a t B e lt W a rn in g
5 6 7 8
J24(A), U1(B)
(IG) (IG) Occupant Classification ECU
Taillight and
D1(A), D2(B), D76(C) Illumination
Combination Meter System< 12–5>
7. 5A 10A
MET GAUGE
(S/D)
(S/D)
GR
D77 FSR+ FSR–
Hazard Warning Signal SW 9 3
PANEL1 Fuse
8 A 4 A
Seat Belt
Driver' s
PAON ILL–
Airbag
< 12–7>
1 4M 15 4S
LED Driver IG+ PBEW P–AB
sic
6 8 10
CPU
(S/D)
(S/D)
(S/D)
(H/B)
(S/D)
GR
O
R
Y
B
CAN Controller
D27
(H/B)
GR
B
Y
Passenger Seat Belt Warning Lamp 2
DIM
CAN I/F Passenger' s Seat Belt/
Airbag Indicator (ON/OFF)
IG+ PBEW P–AB PAON ILL–
YARIS (EM01V0U)
6 3 5 1 4
1 A 21 A 20 A 24 A 9 B (H/B)
(H/B)
(H/B)
GR
9 C (S/D)
R
(H/B)
(H/B)
(H/B)
W
O
Y
14 4S 3 4E
(H/B)
BR
oe O
Communication
System (CAN)
32 4E 15 4E
Multiplex
< 8–2>
G
B
17 A 23 A 12 B 13 B
P–AB PAON FSP+ FSP–
(H/B)
W
D+ D– D2+ D2– CANL CANH DSP+ DSP– DBE+ DBE–
5 A 6 A 8 A 7 A D16(A), J8(C), J9(B) 22 A 13 A 14 C 13 C 11 C 12 C
Junction Connector
lec
Y–G
Y–R
Y–B
Y–R
R
Y
D40
1 A 2 A 4 A 3 A
D18(A), W1(B), W2(C)
D+ D– D2+ D2– Spiral Cable 11

Communication
2 1 4 3
2 B 1 B 2 C 1 C LSP+ LSP– LBE+ LBE–
Multiplex
(H/B)
W–B
BR
W1(B), W2(C) J10
Airbag Squib Front Seat Inner Belt (Driver' s Side)
(Steering Wheel Pad)
3 6A
.ir D3 D2
313
M
18 YARIS (Cont' d)
314

na
S e a t B e lt W a rn in g
9 10 11 12
J24(A), U1(B)
7. 5A 7. 5A
IGN ECU–B
DIA GND BSW BGND SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 SVC2 SIG2 SGD2 SVC4 SIG4 SGD4 +B IG
2 A 3 A 9 A 5 A 11 B 7 B 1 B 5 B 9 B 3 B 12 B 8 B 2 B 6 B 10 B 4 B 1 A 7 A 2
1 4D 1
sic
W–B
GR
BR
SB
W
O
O
G
G
R
R
P
V
L
L
7 JD2 6 JD2 1 JD2
25 AA2
2 1 1 2 3 1 2 3 1 2 3 1 2 3
RBE+ RBE– SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 SVC2 SIG2 SGD2 SVC4 SIG4 SGD4
G
L
O
15 4A 30 4B
8
YARIS (EM01V0U)
J11 U2 U3 U4 U5 D36
Front Seat Inner Belt Occupant Classification Occupant Classification Occupant Classification Occupant Classification
Junction Connector
Assembly (Front RH) Sensor (Front LH) Sensor (Rear LH) Sensor (Front RH) Sensor (Rear RH)
11
17 4E 12 4H
oe
P
W–B
lec
D1
.ir
19 YARIS
na
EPS
1 2 3 4
(IG) (BAT) (IG)
7. 5A 50A 10A
MET EPS ECU–IG
1 4M 1 7 4S
sic
Data Link Connector 3< 7–2> < 7–3>
W
R
B
c1(D)
Junction Connector
D36(A), D37(B)
YARIS (EM01V0U)
8 B

1 A
M
oe
LG
P
L
b1(C)
W
R
R
B
B
P/S
Speedometer
1 A 6 B 2 B 11 B 1 C 2 C 6 D 5 D 7 D 8 D
LED Driver
PIG IG SIL TS M1 M2 TRQV TRQ1 TRQ2 TRQG
CPU
CANH CANL SPD PGND
Combination Meter
CAN Controller
1 B 7 B 5 B A19(A), D31(B), b1(C), c1(D) 2 A
Power Steering ECU
CAN I/F
R
D1
21 20 24
lec Combination Meter< 27–3>

W–B
BR
D3
.ir A3
315
M
316

na
P o w e r W in d o w ∗ 1 : w/ Rear Power Window
1 2 3 4
G1(A), (B)
(BAT) (BAT) (IG) Power Window Master SW
A28
120A ALT
7. 5A Fusible 10A
ECU–B Link Block ECU–IG
B U D D U
2
1 6 A 16 A 15 A 4 A 3 A (∗1)
1 15 B 16 B 18 B 12 B 10 B (∗2)
sic B
GR
Interior Light System< 11–4>
P
1 4G
2 GD2 11 GD2 10 GD2
R
L
PWR 1 2
M
Relay
G4
GR
P
Power Window Regulator Motor
(Front LH)
YARIS (EM01V0U)
21 4A
25 AA2 1 11 FD2 10 FD2

13 26 5
20A 20A PWS DCTY IG
30A
RL RR POWER
oe
DOOR DOOR
Main Body ECU
BECU
2
L
17 4E 1 4A 19 4A 2 4H 11 4H 30 4B
W–B
GR
SB
SB
P
L
L SB
A
SB
B
lec
L
2 FD2 5 2
L 3
F1
Power Window SW (Front RH)
Down
Up
4 1
W–B
G
R
D1
.ir 2
F4
M
1
Power Window Regulator Motor (Front RH)

20 YARIS (Cont' d)
na
P o w e r W in d o w
5 6 7 8
G1(A), (B)

U D U D E
12 A 13 A 10 A 18 A 1 A (∗1)
7 B (∗2)
sic
G
R
Y
B
8 GD2 9 GD2 17 GD2 18 GD2
G
R
Y
B
YARIS (EM01V0U)
11 JD1 10 JD1 2 JD1 1 JD1
G
R
Y
2 IJ1 3 IJ1 2 HJ1
oe 3 HJ1
W–B
G
G
R
SB
A
SB
B
lec
SB
SB
Power Window SW (Rear RH)

Power Window SW (Rear LH)
1 IJ1 5 1 1 HJ1 5 1
SB 3 SB 3
Down
Down
Up
Up
H1
I1
4 2 4 2
Y
3 5B
1
I2
M
2
Power Window Regulator

1
H2
M
2
Power Window Regulator

D1
.ir
317
Motor (Rear LH) Motor (Rear RH)
M
318

na
D o o r L o c k C o n tro l
1 2 3 4
D33(A)
7. 5A 25A 10A 7. 5A
BCTY(H/B)
ACC IG ALTB BECU KSW DCTY PCTY RRCY LGCY(S/D) GND1 TRLY HAZ LSWP UL2 L2 ACT– ACT+
2 21 5 4 6 9 26 20 22 23 1 19 25 5 A 16 14 3 2
1
A
sic
B
FLASH Relay< 10–4>

T–LP Relay< 12–1>
30 4B 7 4D 21 4A 24 4A 20 4A 5 4A 7 4A 17 4E 1 4S 15 4H 16 4H 18 4H 8 4H
25
L L
W–B(S/D)
AA2
W–B
YARIS (EM01V0U)
O
G
P
L
System< 16–4>
Key Reminder
< 11–2> < 11–4> < 11–5>

Interior Light System
oe
17 JD1 9 FD1 8 FD1 7 FD1 20 FD1 10 FD1
BR
O
G
P
L
7 5 6 1 4
LSSR UL L UL L
Detection
Unlock
Lock
Unlock
M
E
8 F5
Door Lock Assembly (Front Passenger' s Side)
lec
W–B
W–B
D
(S/D)
W–B(H/B)
E
W–B(S/D)
F
1 6B 3 6A 6 6B
.ir D1 D2
∗
na
1 : w/ Rear Power Window
D o o r L o c k C o n tro l ∗ 3 : w/ Power Window
5 6 7 8
D33(A)
Main Body ECU
LSWD UL3 ACTD LSR HRLY CANL CANH L1 UL1 HORN

21 A 14 A 2 A 24 A 3 A 22 A 23 A 12 10 15
Lock Assembly
A
(S/D)
M
O
Back Door
sic
SB
LG
B
Y
L
N3
1 2
(H/B)
(H/B)
GR
P
C
HORN Relay< 25–3>

Communication
7 4H 17 4H 3 4A 4 4A 7 MN1 6 MN1 8 JD2 4 4H 5 4H 10 4C 11 4E
System (CAN)
(H/B)
(H/B)
(S/D)
Multiplex
O
B
B
GR
Assembly< 9–4>
< 8–1>
P
BR(S/D)
LG
O
Dimmer SW
8 MJ1 9 MJ1
Headlamp
O(S/D)
YARIS (EM01V0U)
(H/B)
(H/B)
GR
P
5 GD1 6 GD1 6 FD1 5 FD1
BR
SB
W
Y
L
8 B 2 B 7 B 1 B
9 GD1 8 GD1 7 GD1 20 GD1 10 GD1
oe
BR
O
G
P
L
(H/B)
(H/B)
(S/D)
(S/D)
11 A 5 A J28(A), J29(B) 12 A 6 A
(∗4)
(∗4)
(∗3)
(∗3)
BR
BR
BR
BR
O
O
G
Junction Connector
8 10 9 1 4

GR
GR
P
P
2 A 9 A (∗1)

LSSR UL L UL L
3 2 1 B 9 B (∗2) 4 5 2 3
(Driver' s Side)
L UL L UL
Detection

Unlock
8 HJ1 9 HJ1 8 IJ1 9 IJ1

Lock
Unlock
Unlock
Unlock
Unlock
Lock
Lock
Lock
GR
GR
P
D30
E
G7
F7
Door Lock Assembly
Door Lock Assembly
Unlock
4 1 4 1
Lock
4 6 4
G1(A), (B)
E
L UL Unlock Unlock L UL
7 G5 Detection Detection
(Rear RH)
(Rear LH)
Door Lock Assembly (Driver' s Side)
(H/B)
(S/D)
W–B
W–B
M M
1 A (∗1)
E LSSR E LSSR 7 B (∗2)
H3
I3
9
lec 6 9 6
W–B
W–B
(∗4)
(∗3)
(S/D)
(S/D)
(S/D)
(S/D)
W–B
W–B
13
O
D40
Junction
12 HJ1 13 HJ1 12 IJ1 13 IJ1 Connector
W–B
11
(S/D)
(S/D)
(S/D)
(S/D)
W–B
W–B
O
W–B W–B
D
(H/B)
W–B
(S/D) (S/D)
W–B(H/B)
E
W–B(S/D)
F
1 5B 4 5B 3 5B
.ir D1
319
M
21 YARIS (Cont' d)
320

na
W ire le s s D o o r L o c k C o n tro l T h e ft D e te rre n t ∗ 5 : w/ Theft Deterrent System
9 10 11 12
D33(A)
Main Body ECU (BAT) (BAT) (IG)
15A 7. 5A 10A W–B W–B

DOME ECU–B ECU–IG
W–B
SRX STX PRG RDA
18 A 19 A 17 A 16 A 2 2 1 A (S/D)
2 B (H/B) 2
Security Horn
Courtesy SW
Engine Hood
1 1 7 4S L
A18(A), (B)
sic
L
A23
B
25 AA2 2 A (S/D)
(∗5)
(∗5)
1
W
O
R
P
L
1 B (H/B)
L
12 MN1
Junction Connector
13 4B 30 4B
(S/D)
(H/B)
P
P
8 B
D37(B)
O
4 4P 5 4P 12 4H 9 B 11 JD2 15 MJ1
YARIS (EM01V0U)
P
11 A
(S/D)
(H/B)
(H/B)
(S/D)
P
P
L D36(A), D37(B)
Junction Connector
oe
1 B 16 AD5 15 AD5 16 JD2
GR
B
D38(A), D39(B) 3 B 2 B
Junction Connector
(S/D)
(H/B)
BR
(H/B)
L
O
8 A
11 13 9 4 15 6
+B1 +B2 IG DSWH SH– LSR(H/B)
L
LUG(S/D)
BRK– BRK+ E IND KSW

16 JD1 15 JD1 14 JD1 25 24 16 29 D26 7
G Theft Warning ECU
W–B
(∗5)
(∗5)
O
Y
(S/D)
W
18
D35
(H/B)
LG
3 2 5 Junction
Connector
PRG RDA +B 16
lec LG 2 2
Unlock Warning SW< 16–4>
Door Lock Assembly

(S/D)
2
Detection
Detection
Unlock
Unlock
Position SW
Back Door
(Luggage)
GND
J43
N4
J13 1 D25
Door Control Receiver Security Indicator Lamp 1 1
W–B
W–B
D40
(H/B)
(S/D)
W–B
W–B
W–B
10 11 W–B
7 8
W–B B W–B W–B
MJ1 MN1
(H/B) (H/B) (H/B) (H/B)
.ir
W–B
3 6A
J2 D2 N1 J2 A1
22 YARIS
na
F ro n t W ip e r a n d W a s h e r
1 2 3 4
(IG) (IG)
15A 20A
WSH WIP
2 4B
1 4H 36 4B
sic
B
(H/B)
L
2
A26
(S/D)
Junction
L
Connector
3
B
L
Y
(H/B)
L
5 AD2 2 AD2
YARIS (EM01V0U)
4 4E
Y
L
1
D5(A), D6(B)
A5 Windshield Wiper SW Assembly
Windshield 3 B 4 B
M
Washer Motor +1 +2
25 4B
2
oe
+B INT1 INT2 +S +1 +2 B1
W
Y
L
MIST Washer SW
G
3 5 1 2
Wiper SW
OFF WF EW
+2 +1 +S B
INT Off
LO On
1 AD2
HI
G
+S INT1 INT2 B1
lec E
4 A9
W–B
2 4E
+B +S W E
W–B
Wiper Relay
+S +B WF EW
1 B 2 B 3 A 2 A 17 4E
W
W–B
W–B
G
B
.ir D1 A1
321
M
23 YARIS
322

na
R e a r W ip e r a n d W a s h e r S h ift L o c k
1 2 3 4
(IG) (IG) (IG) (ACC)
D5(A), D6(B)
Windshield Wiper SW Assembly
7. 5A ACC2
15A 15A 10A D43
RR WIP WSH WR +1R EW GAUGE Fuse Block
Rear Wiper and

Wash
Washer SW
Off 2
25 4A 2 4B 2 4P
Electronic Controlled Transmission

sic
On
and A/T Indicator System

On+Washer
W
L 5 B 7 A 2 A
Stop Lamp SW< 14–2>

2
A26
4 MJ1 Junction Connector
W–B
< 5–19>
O
B
L
1
18 JD1
L
YARIS (EM01V0U)
L
A4
W
M Rear Washer Motor
G
6 MJ1
2 1 3 9 7 6
oe
IG AT3 NSSD STP ACC
D22
L
L
2 MN1 10 AD2 9 MN1
SLS+ SLS– KLS+ E

12 8
Shift Lock Solenoid
W–B
L
W
1 2
lec 1
Key Interlock
N1
B L
Solenoid
Rear Wiper Motor Assembly
D13
M
2
12
W–B 5 D40
Junction Connector
11
2 4E
W–B
17 4E
W–B
D1
.ir 3 6A
D2
24 YARIS
na
R e m o te C o n tro l M irro r C ig a re tte L ig h te r/P o w e r O u tle t
1 2 3 4
(ACC) (ACC)
7. 5A 15A
ACC CIG
13 B
D34(A), D35(B)
GR
Junction Connector
6 4S 3 4Q
19 A
sic
GR
GR
D12
8 Outer Mirror SW 1
D14
B ACC Cigarette Lighter or Power Outlet
7 E
Operation SW
E
YARIS (EM01V0U)
Right/
Down
Down
Right
Left/
Left
Up
Up
MH MV
Select SW
Left Right Left Right
oe
(S/D)
(H/B)
W–B
W–B
HL HR VL VR M+
5 2 4 3 6
SB
SB
O
P
14 5
12 D40
Junction Connector
13 D38 11
Junction
SB
SB
G
Connector
13 GD1 12 GD1 12 FD1 13 FD1 14 FD1 14 GD1
lec
(H/B)
W–B
W–B
SB
SB
W
B
3 5 3 5
Outer Rear View Mirror (RH)
Outer Rear View Mirror (LH)
MH MV MH MV
M M M M
M+ M+
G2
F2
4 4
W
6 6A 3 6A
4 5A
D1
.ir D2
323
M
25 YARIS
324

na
R e a r W in d o w D e fo g g e r H o rn
1 2 3 4
(BAT) (IG) (IG) (BAT)
10A GAUGE
30A 7. 5A 10A
DEF A/C HORN
2 2
sic
DEF HORN
Relay Relay
2 4F 12 4Q 10 4S 7 1A 8 1A
LG
O
G
B
B
15 DE1 12 DE1 28 4B 17 AA2
YARIS (EM01V0U)
20 JD2
Main Body ECU
< 21–8>
O
18 4E
(H/B)
G
B
15
(S/D)
E10
B
oe
Junction Connector
1
17
1 BA1
J45
(H/B)
(H/B)
Noise Filter
B
P
E6
Rear Window Defogger SW 2 3
2 RDEF IG+
1 MJ1
(S/D)
B
(H/B)
G
B
B
Rr E
1
J31
Noise Filter
1 A (H/B)
1 D (S/D)
1 B (H/B)
1 C (S/D)
J44(D), M2(A), O1(B), (C)
Rear Window Defogger
Rear
Window
Defogger SW
lec
Off
On
DEF
1
E
8 A
HO
2 B (S/D)
1 C (H/B)
D3(A), V1(B), (C)
Spiral Cable
1
B2
W
Horn
W–B
W–B
V1(B), (C)
Horn Steering Pad SW
5 7
D40
Junction Connector 9 DE1 E10
Junction Connector
11 5
W–B
W–B
B
O1
3 6A
D2
.ir
26 YARIS
na
A u d io S y s te m ∗ 1 : H/B 5–Door
∗ 2 : H/B 3–Door
1 2 3 4
(ACC) (BAT)
J39 J38
7. 5A 15A 2 1 2 1
ACC DOME
J27 J26
2 Speaker (Rear LH) Speaker (Rear RH)
14 4D 1 2 1 2 1
sic
I4 H4
2 1 2 1
(S/D)
(S/D)
(S/D)
(S/D)
(∗2)
(∗2)
(∗2)
(∗2)
W
R
Y
B
GR
(∗1)
(∗1)
(∗1)
(∗1)
W
W
R
R
5 IJ1 4 IJ1 5 HJ1 4 HJ1
8 AD2 D32
Antenna Amplifier
YARIS (EM01V0U)
(∗1)
(∗1)
(∗1)
(∗1)
W
R
Y
B
B
1
1 JD3 5 JD2 4 JD2 11 JD3 10 JD3 15 JD2 14 JD2 20 JD3
B
L
(H/B)
(H/B)
(H/B)
(H/B)
Y B W R
R
oe
Y
B
(S/D) (S/D) (S/D) (S/D)
D10(A), D11(B), D74(C)

3 A 4 A 8 A Radio Receiver Assembly 6 B 2 B 3 B 1 B
ACC B ANT RL– RL+ RR– RR+
FR– FR+ FL– FL+ GND SPD ALI ARI ASGN AUXI
5 A 1 A 6 A 2 A 7 A 3 C 17 C 15 C 16 C 19 C
(Shielded)
(S/D)
W–B
GR
R
Y
lec
Meter< 27–2>
Combination
1 2 3 4
18 FD1 17 FD1 18 GD1 17 GD1 ALO ARO ASGN AUXO
GR
P
L
D75
Stereo Jack Adapter
2 1 2 1
F6 G6
Speaker (Front Door RH) Speaker (Front Door LH)
D3
.ir
325
M
326

na
C o m b in a tio n M e te r ∗ 1 : S/D w/ Tachometer
∗ 2 : S/D w/o Tachometer, H/B
1 2 3 4
(IG) (BAT) (IG)
10A 7. 5A 7. 5A
ECU–IG ECU–B MET
Illumination System
< 12–3> < 12–4>
2
Taillight and
24 4B 1
sic
25 AA2 30 4B 2 4S 1 4M
L
L
B
B
L
16
A25
16 B (H/B) D1(A), D2(B), D76(C)
Junction
Connector 2 A 1 A 14 A 16 C (S/D) Combination Meter
20
YARIS (EM01V0U)
(∗2)
(∗1)
(∗1)
(∗1)
(∗1)
(H/B)
(H/B)
(H/B)
(H/B)
(Front RH)
(Front LH)
(Luggage)
MAINT REQD
Graphic
Tail (Canada)
Temp. Cool
Temp. Hot
Seat Belt
11 CA2
Door
Driver' s
Pointer
Airbag
Door
Door
Door
Door
ABS
Dial
P/S
5V IC
oe
(∗2)
(∗1)
(∗1)
(∗1)
(∗1)
B
Display
Illumination I/F LED Driver
CPU
CAN Controller
Speedometer
Tachometer
I/F I/F
(H/B)
(H/B)
I/F I/F I/F (H/B)

I/F I/F I/F I/F I/F
Clock CAN I/F
(S/D)
Buzzer SW TRIP
P
11
Drive
Monitor
P
SW
lec 3 A 24 A
P
17 A 16 A 19 C 18 C 17 C 7 A
(H/B)
15 A 21 A 20 A 9 B (H/B)
9 C (S/D)
(S/D)
(S/D)
(S/D)
GR
AD3
L
G 5 11 12
BR
SB
V
E TX+1 +S
6 AA2 ODO/TRIP SW
1 4C 8 4D 8 4C Clock SW
SRS System< 18–6>

3
and Gage Assembly
W–B 20
System< 12–4>
Fuel Suction Pump
D36 D77
B
Taillight and

Illumination
Junction
Gage
Connector
13 4A 22 19 26 4B
12 CA2 13 CA2 23 AA2
(S/D)
J5
W
W–B
V
W–B
P
2
BR
1
IG+
C21
3
Speed Sensor
SI
2
SE
A1 J1
O
D3
Radio
Receiver
Assembly
< 26–3>
Power
Steering
ECU< 19–3>
.ir Engine Control
Module< 5–14>
327
YARIS (EM01V0U)
CRUISE
P
(∗3) (∗3)
27 YARIS (Cont' d)
R
(∗3) (∗3)
LED Driver
N
(∗3) (∗3)
D
(∗3) (∗3)
Combination Meter
D1(A), D2(B), D76(C)
V V
2 B
2 C
19 AA2
18 AD3
2
(∗3) (∗3)
V
1
2
L
(∗3) (∗3)
A10
Brake Fluid Level
Warning SW
BRAKE (USA)
Brake (Canada)
W–B
Washer
2
1
W–B W W
E
S
10 B
10 C
A1
22 AD3
(S/D)
A22
6

na
Charge
(S/D)
1 B
1 C
Charging System< 3–3>
Head (USA)
13 B
13 C
Headlight System< 9–3>
sic
Oil Pressure
Y Y Y
12 B
12 C
18 AA2
6 CA1
19 AD3
C o m b in a tio n M e te r
22 C
Y
Door
(Rear LH)
(∗1) (∗1)
20 C
oe
Interior Light
7
System< 11–7>
Door
(Rear RH)
1
(∗1) (∗1)
21 C
C16
Malfunction
Indicator Lamp
Engine Control
4 B
4 C
System< 5–19>
Engine Oil Pressure SW
lec
Beam
Headlight
14 B
14 C
Headlight System< 9–3>

System< 9–3>
11 C (S/D)
11 B (H/B)
Turn RH
15 B
15 C
Turn Signal and

.ir
Hazard Warning Light
System< 10–3>
Turn LH
(S/D) (S/D)
8 B
8 C
8
∗ 3 : S/D A/T
Front Fog
(H/B) Front Fog Light
System< 15–2>
7 C (S/D)
7 B (H/B)
M
28 YARIS
328

na
C o o lin g F a n
1 2 3 4
(BAT) (IG)
30A 10A
RDI ECU–IG
1 24 4B
sic
B
L
Junction Connector
16
B 17
A25
18
YARIS (EM01V0U)
LG
B
B
5 1B 6 1B 1 1
oe
2 3
FAN NO. 1 FAN NO. 2 4

Relay Relay
1 5
8 1B 7 1B 1 1 1
W–B
LG
O
L
L
lec
Radiator Fan Resistor
Cooling Fan Motor
2
2
3 AA2 4 AA2
M
A8
A14
LG
O
1
1
W–B
LG
W–B
W–B
A2
.ir A1
Memo
na
sic
oe
lec
.ir
YARIS (EM01V0U)
329
330

na
A ir C o n d itio n in g
1 2 3 4
E5
(BAT) (IG) (IG) A/C SW
40A 10A 7. 5A L B
HTR GAUGE ∗ 1 : w/ PTC Heater A/C
A/C SW
∗ 2 : w/o PTC Heater Off
∗ 3 : w/ Defroster Mode Detection SW
2 ∗ 4 : w/o Defroster Mode Detection SW On
∗ 5 : w/ A/C SW
1 10 4S
∗ 6 : w/o A/C SW
(∗5)
sic
(∗3 ∗5)
O
5 2
L B
Detection
Defroster
4 HTR
(∗4 ∗5)
Off
Mode
(∗5)
Relay 12 DE1
SW
L
(∗3 ∗5)
On
3 1
(∗3 ∗5)
1 4L 17 4E 7 4F 5 4Q
O
(∗3 ∗5) (∗6)
YARIS (EM01V0U)
L B E
B
E10 2 4 3
P 17
1 ED1 BR
LG
V
P
18 16
oe
Y
3
IG+
B
8 A 15 A 16 A
IG+ A/C LED
Rear Window Defogger SW

13 DE1 IG MAX– E8(A), E9(B)
HOT
A/C Amplifier
2
Max
SW
Hot
Off
M E4
Blower Motor On HEAT B/V SBLW GND SG–2 TE
1
E3 14 B 14 A 9 A 12 A 4 A 10 A
Blower Resistor SG A/C B
E6
L
L 4
8 7 6
W–B
LG
W–B
(∗2)
(∗2)
(∗2)
(∗2)
2 3 1
BR
LG
LG
L
L
(∗1)
L
W–B
BR
G
lec
Junction Connector
10 6 7
14
E LO HI M2 M1 1 2 4 L 12
E10
E10
0 Junction Connector (∗2)
13
1 3 5
(∗2)
(∗1)
GR
L
L
W–B
W–B
2
R
3
Blower SW
5
D40
2 ED1 9 DE1 Junction Connector
4
E1
A/C Thermistor No. 1

1
5 9 11
W–B
W–B
W–B
R 3 6A
.ir
E2
W–B
2
D1 D2 D2
29 YARIS (Cont' d)
na
A ir C o n d itio n in g
5 6 7 8
(BAT) (BAT)
40A 30A
HTR HTR
SUB2 SUB1
Generator< 3–2>
2 2
1 1
Headlamp Dimmer SW
(∗1)
sic
R
W
Assembly< 9–4>
(∗1)
(∗1)
P
R
(∗1)
W
(∗1)
15 CA1
2 2 2 2 1 1
2 5 2 5 1 5
(∗1)
(∗1)
(∗1)
(∗1)
LG
O
R
P
W–B
(∗1)
HTR HTR HTR
YARIS (EM01V0U)
SUB2 SUB3 SUB1

14 DE1 7 AE1 2 AE1 5 AE1 Relay Relay Relay
1 3 1 3 2 3
2 2 2 2 1 1
(∗1)
(∗1)
(∗1)
(∗1)
BR
LG
R
P
W–B
oe
(∗1)
(∗1)
(∗1)
V
B
E8(A), E9(B) W–B
A/C Amplifier 2 A 3 A 23 B 24 B 12 B 10 B (∗1)
TX+ TX– HLS ALT PTC3 PTC2
L
(∗1)
R
(∗1)
3 1 2
TAM SG–1 S5–3 PRE SOL+ PTC1 B B B
5 A 11 A 1 A 6 A 7 A 9 B
1 AE1
A17
(∗1)
GR
LG
W
V
PTC Heater
10 AE1 9 AE1 4 AE1 3 AE1
lec 6 AE1
GR
LG
W
3 2
+ PR
10 BA1 7 CA1 2 CA1
11 BA1
W
–
LG
W–B
W–B
1 A3
2 A/C Pressure Sensor 1
C8 W–B
Ambient Temp.
A/C Compressor
Sensor
W–B
B5
2
1
4 6 5
A25
Junction Connector
.ir A1
331

2007 Yaris

Uploaded by

Copyright:

Available Formats

2007 Yaris

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

2007 Yaris

Uploaded by

Copyright:

Available Formats

FOREWORD

This wiring diagram manual has been prepared to provide

Refer to the following manuals for additional service

Manual Name Pub. No.

All information in this manual is based on the latest product

HOW TO USE THIS MANUAL . . . . . . . . . . . . . . . B . . . . 3

ELECTRICAL WIRING ROUTING . . . . . . . . . . . G . . . . 46

POWER SOURCE (Current Flow Chart) . . . . . J . . . . 252

CONNECTOR LIST . . . . . . . . . . . . . . . . . . . . . . . . K . . . . 258

PART NUMBER OF CONNECTORS . . . . . . . . . L . . . . 276

No. Section Description

INDEX Index of the contents of this manual.

HOW TO USE THIS

D ABBREVIATIONS Defines the abbreviations used in this manual.

INDEX Index of the system circuits.

This manual provides information on the electrical circuits installed on vehicles by

When the circuit operation is understood, begin troubleshooting of the problem

Rear Combination Lamp (LH)

[I] : Indicates a shielded cable.

The first character of the connector code indicates

Symbol ( ) indicates the male terminal connector.

[P] : Parts Location

Code See Page Relay Blocks (Relay Block Location)

[R] : Junction Block and Wire Harness Connector

[S] : Connector Joining Wire Harness and Wire Harness

[T] : Ground Points

Code See Page Ground Points Location

[O] : Explains the system outline.

Pressure SW W–B W–B Fog Lamp

Windshield W–B W–B Brake Fluid Level

Battery 30A AM2 2 Fusible Link Block 6 10A HAZARD

100A ALT 6 60A ABS 5

Engine Room R/B (See Page 20)

[B] : Junction Connector

Junction connector in this manual include a short terminal which is

[C] : Parts Code

[D] : Connector Color

L PART NUMBER OF CONNECTORS

A3 Air Flow Meter 90980–12292 B24 Blower SW (Rear Heater) 90980–10463

A5 Pressure SW 90980–10943 B26 Door Courtesy SW (Front RH) 90980–12470

A9 Brake Vacuum Warning SW 90980–11252 B30 Fuel Filter Warning SW 90980–11003

A12 Airbag Sensor (Front RH) 90980–11856 B34 Junction Connector

A13 Airbag Squib B35 Junction Connector 90980–11398

[A] : Part Code

[B] : Part Name

[C] : Part Number

CONTINUITY AND RESISTANCE CHECK

Press Down Press Down

10 1. PREPARE THE SPECIAL TOOL

Example: Up 3. DISENGAGE THE SECONDARY LOCKING DEVICE OR

(a) Locking device must be disengaged before the terminal

[A] For Non–Waterproof Type Connector

HINT : The needle insertion position varies according to the

[Retainer at Temporary Lock Position]

Example: Secondary ”Case 2”

Example: [B] For Waterproof Type Connector

Example: Terminal Retainer ”Case 2”

4. INSTALL TERMINAL TO CONNECTOR

(a) Insert the terminal.