UENR4683-03

July 2017

EN-C511 CONNECT TO

UENR4683-03 VOL 1 of 2
EN-C122 CONNECT TO NRS FLOW BAL VALVE
PJ-C7 AIR INLET TEMP SENSOR ACTR UP

(Dimensions: 56 inches x 35 inches)

PJ-C8

BRAKE
ACTUATOR

INTAKE MANF
PRESS. SENSOR C9.3 Industrial Engine
ARD FUEL FLOW DIVERTER VALVE AIR SHUTOFF BREAKER Electrical System
SCR TEMP PROBE CS91-UP
ARD FUEL PUMP AIR SHUTOFF RELAY
TERM RES CAN B PJ
AIR SHUTOFF SOL
MANUAL PRIMING SWITCH TERM RES CAN B EN
NRS DIFFERNTIAL
INJECTOR METER RAIL PRESS SENSOR TDC SERVICE PROBE

42 Page,
PRESS SENSOR
EN-C800 CONNECT TONC-C1 NRS VALVE ACTUATOR NRS INTAKE
OPTIONAL COOLANT LEVEL SENSOR NRS TEMP SENSOR PRESS SENSOR
FUEL PUMP SOL FORE 1
CM-C1 INJECTOR 6 INJECTOR 4 INJECTOR 2
FUEL PUMP SOL AFT 2
CM-C5 TO STARTER BATTERY +
BAROMETRIC PRESS. SENSOR INJECTOR 5 INJECTOR 3 INJECTOR 1
CM-C3 TO STARTER SOLENOID
CHARGE AIR COOLER OUTLET TEMP Volume 1 of 2: Customer Interconnect Harness
CM-C2 TOP VIEW
CONNECT TO ASO ENABLE /
TOP SPEED/TIMING “A” RUN
REMOTE SHUTDOWN / DEF LAMP
TERM RES CAN A CM ECM FUEL COOLED Harness And Wire Electrical Schematic Symbols
CONNECT TO COOLANT COOLANT DIVERTER
Symbols
LEVEL SENSOR VALVE

CONNECT TO FUEL Pressure

T

Temperature Level Flow Circuit Breaker

PRIMARY PUMP RELAY Symbol Symbol Symbol Symbol Symbol

Symbols and Definitions

CM-C15 TO BATTERY - Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.
CONNECT TO AIR
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
INLET TEMP SENSOR circle indicates that the component has screw terminals and a wire can be disconnected from it.

DEF LINE Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
CM-C4 TO BATTERY + HEATER RELAY
No circle indicates that the wire cannot be disconnected from the component.

BOTTOM SPEED/TIMING “B” CRANK Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.

MAIN PTU Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.
CRANKCASE PRESS. SENSOR POWER RELAY
PJ-C6 CONNECT TO
REAR VIEW DEF DOSING PUMP Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
ENGINE OIL PRESS SENSOR ECM CHASSIS STARTER DIESEL EXHAUST MODULE RIGHT VIEW
PETU INTERCONNECT Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
T
the gauge of the temperature or pressure.

LEFT SIDE VIEW Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.

DCU Solenoid: A solenoid is an electrical component that is activated by electricity. It has a

coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is

activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.

Harness and Wire Symbols

Wire, Cable, or Harness Harness Identification Letter(s):

DPF INTAKE PRESS #1 SENSOR Assembly Identification: Includes

Harness Identification Letters and
(A, B, C, ..., AA, AB, AC, ...)
Harness Connector Serialization Code:
Harness Connector Serialization
The "C" stands for "Connector" and the
DPF DELTA PRESS DPF #1 INTAKE TEMPERATURE
Codes (see sample).

AG-C4 L-C12
number indicates which connector in the
harness (C1, C2, C3, ...).
VLPM 111-7898 3E-5179
L-C12
ARD FUEL NOZZLE HEATER AFTERTREATMENT 1 SEC AIR PRESS
3E-5179
ARD FUEL NOZZLE HEATER RELAY Part Number: for Connector Plug 1
Part Number: for Connector Receptacle
2
ANALOG FD/DPF INTAKE AFTERTREATMENT #1 ID # MODULE Plug Receptacle
DEF INJECTOR (8L) Pin or Socket Number
5A
ARD IGNITION XFMR PRIMARY ARD FUEL PRESS #2 MAIN 1 Deutsch connector: Typical representation
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
2 sockets and the receptacle contains all pins.
ARD AIR FLOW CONT ACTUATOR ARD FUEL PRESS #1 (PILOT) DIESEL EXHAUST MODULE LEFT VIEW 1 Sure-Seal connector: Typical representation Harness identification code:
325-AG135 PK-14
of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color
ARD FUEL #2 CONT ACTUATOR © 2017 Caterpillar CAT, CATERPILLAR, their respective logos, “Caterpillar Yellow”, and the POWER EDGE trade dress as well as
All Rights Reserved corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.
AFTERTREATMENT #1 ARD FUEL #1 CONT ACTUATOR
CONNECT TO GAS TEMP #1
AFTM OUTLET NOX SENSOR SCR TEMP INLET
PT-C917, PU-C917
CONNECT TO
AFTM INLET NOX SENSOR PT-C918, PU-C918
CIRCUIT BREAKER 7
TERM RES CAN C PJ ALTERNATOR TERM RES CAN C CIRCUIT BREAKER 1
ELECTRONIC
COOLANT TEMP DISPLAY
PC-C2 SENSOR CONNECT TO CIRCUIT BREAKER 6
SCR LINE HEATER#2 KEYPAD CIRCUIT BREAKER 2
PC-C3 CONNECT TO
AIR INLET TEMP SENSOR MODULE CIRCUIT BREAKER 8
CIRCUIT BREAKER 4
PC-C800 CONNECT TO SERVICE TOOL
NC-C1 CONNECTOR

SERVICE CONNECTOR START SWITCH

INSTRUMENT GP FRONT VIEW

DIESEL EXHAUST MODULE FRONT VIEW

SCR LINE HEATER #1

FUEL PRESS BEFORE FILTER SMMS
DEF TANK HEADER
DIODE
FUEL TEMP SENSOR
FUEL PUMP
RELAY
FUEL PRESS AFTER FILTER SHUTDOWN
RELAY

SCR LINE HEATER #3

RIGHT SIDE VIEW FRONT VIEW C-C7
DIESEL EXHAUST MODULE TOP VIEW INSTRUMENT GP REAR VIEW
 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
PETU 24 V
DCU PT-C27
PT-C552
378-3181
9X1054 30
101-PT28 RD-12-GXL 1
86
SCR LINE HEATER #2 RTN 1 L930-PT3 YL-16-TEFLON N828-PT32 YL-18-GXL 5
SCR LINE HEATER #1 RTN 2 N894-PT1 YL-16-TEFLON MAIN PTU POWER RELAY 24V
3 E740-PT31 GN-18-GXL 2
85 3E-5239
4 187-PT18 PU-12-GXL 4
5 87
CM-C15 6 101-PT28 RD-12-GXL 3
105-C17 BR-18-GXL 87a
1275483 7 101-PT29 RD-12-GXL
105-C16 BR-18-GXL 105-C30 BR-18-GXL
UENR4683-03 VOL 1 of 2

ELECTRONIC DISPLAY (ENGLISH) C-C2

TO BATTERY (-) 1 A244-CM41 BK-4-SGX
COOLANT DIVERTER VALVE HIGH 8 L929-PT57 BR-18-TEFLON 101-PT30 RD-12-GXL
105-C23 BR-18-GXL 105-C18 BR-18-GXL 9
391-3103 2304009 10 PT-C547
CM-C4 11 128-PT13 PK-14-TXL 128-PT12 PK-12-GXL 9X1054
CAN 1 (+) 1 K900-C37 YL-18-GXL DEF INJECTOR RETURN 12 N895-PT56 PK-18-TEFLON 30
CONNECT TO CM-C2 LOC. I-5 1275484 128-PT14 PK-14-TXL 128-PT16 PK-12-GXL 128-PT11 PK-12-GXL 1

J J
CAN 1 SHIELD 2 C-C7 13 86
CIRCUIT BREAKER 8 TO BATTERY (+) 1 101-CM10 RD-4-SGX 14 C249-PT8 BK-18-TEFLON 5
CAN 2 (+) 3 6T-3643 2130143 15 DEF LINE HEATER RELAY 24V
K900-C8 YL-18-GXL K837-PT10 BR-18-TEFLON 2
85 3E-5239
SOURCING OUTPUT DRIVER 4 1 CAN + 16
C-T11 DEF DOSING PUMP PRESS SIGNAL 17 A370-PT44 GY-18-TEFLON 128-PT11 PK-12-GXL 177-PT6 OR-12-GXL 4
SHORT TO BTRY 1 5 150-C22 OR-12-GXL 15A
101-C40 RD-12-GXL K990-C9 GN-18-GXL 2 CAN - 87
DEF DOSING PUMP SENSOR GND 18 A371-PT45 PK-18-TEFLON 128-PT61 PK-14-TXL 128-PT100 PK-16-GXL 3
BATTERY - 6 229-C12 BK-18-GXL 892-C26 BR-18-GXL 3 CDL DEF DOSING PUMP SENSOR SUPPLY 19 A369-PT43 PU-18-TEFLON 87a
CM-C5 128-PT62 PK-14-TXL
CAN 1 (-) 7 K990-C4 GN-18-GXL 893-C25 GN-18-GXL 4 CDL 20
PT-C914
1275486 21
CAN 2 SHIELD 8 Y737-C15 YL-18-GXL 5 PUMP RELAY CONTROL 1779654
(Dimensions: 56 inches x 35 inches)

CAN 2 (-) 9 Y738-C27 GY-18-GXL 6 PUMP RELAY CONTROL RETURN TO STARTER BATTERY (+) 1 101-CM47 RD-10-GXL 22
CIRCUIT BREAKER 5 23
SINKING OUTPUT DRIVER RELAY 10 298-C50 BK-18-GXL 7 4TH POSITION KEY SW DEF DOSING PUMP PWM SIGNAL 24 J849-PT38 WH-18-TEFLON 177-PT4 OR-18-GXL 187-PT18 PU-12-GXL 1 RD-12 + BAT. INPUT
226-7300 CM-C3 177-PT7 OR-18-GXL 128-PT12 PK-12-GXL 2 WH-12 + BAT. PUMP VLPM
KEYSWITCH 11 105-C16 BR-18-GXL 101-C10 RD-10-GXL 8 TO SMMS 25
BATTERY + 1275485 DEF DOSING PUMP PWM RETURN 26 A366-PT39 BU-18-TEFLON 177-PT5 OR-18-GXL C250-PT22 BK-12-GXL 3 BR-12 GND PUMP 396-6500 24V
12 150-C3 OR-18-GXL 150-C19 OR-14-GXL 9 A4E4 UNSWITCHED PWR
25A TO STARTER SOLENOID 27 177-PT6 OR-12-GXL A283-PT24 BK-12-GXL 4 BK-12 GND MACH
301-C42 BU-10-GXL 10 FROM SMMS 301-CM20 BU-10-GXL 28
149-C28 PU-14-GXL 11 HEATED NOZZLE PWR 29
T788-C29 GN-12-GXL 12 FROM FUEL PUMP RELAY 30 187-PT18 PU-12-GXL
31
ATTACH 25A CIRCUIT BREAKER 150-C32 OR-14-GXL 13 A5E2 UNSWITCHED PWR DEF INJECTOR SIGNAL 32 K840-PT54 GY-18-TEFLON
ELECTRONIC DISPLAY (METRIC) OPTIONAL ATTACHMENT PT-C915
FOR THE 12V INSTRUMENT GP 101-C40 RD-12-GXL 14 TO FUEL PUMP RELAY CB 33
391-3102 34 A283-PT24 BK-12-GXL 2407877
105-C30 BR-18-GXL 15 KEY SW CONNECTS TO MAIN ENGINE CM-C1 35
1 SCR LINE HEATER #2
CAN 1 (+) 101-C41 RD-10-GXL 16 TO A5E2 AND A4E4 AND HEATED NOZZLE HARNESS EN-C120 LOC. G-14 1607689 CONNECT TO C-C7 LOC. J-9 36 A283-PT23 BK-12-GXL 177-PT5 OR-18-GXL 1 BK-18
CAN 1 SHIELD 2
101-C200 RD-10-GXL 229-C48 BK-14-GXL 17 GND (P1/J1) CM-C2 INSTRUMENT PANEL HARNESS 37 A283-PT25 BK-12-GXL L930-PT3 YL-16-TEFLON 2 BK-18 SEE CHART 399-6143 FOR
CAN 2 (+) 3 2970705 38 PRESS HTR #2 LINE P/N
101-C21 RD-14-GXL 101-C10 RD-10-GXL 101-C45 RD-12-GXL 18 TO A4E4 AND KEY SW CB (15A) 1 101-CM10 RD-4-SGX 101-CM26 RD-12-GXL 39
SOURCING OUTPUT DRIVER 4
A4E4 UNSWITCHED PWR 2 101-CM36 RD-14-GXL F711-CM44 YL-18-GXL 1 GLOBAL CAN A (+) A364-PT40 YL-18-TEFLON
150-C33 OR-14-GXL 19 40
SHORT TO BTRY 1 5
3 101-CM37 RD-10-GXL F712-CM51 GN-18-GXL 2 GLOBAL CAN A (-) 41 A366-PT39 BU-18-TEFLON
BATTERY - 6 CIRCUIT BREAKER 7 42
DIGITAL SENSOR SUPPLY +8V 4 A700-CM34 OR-18-GXL 892-CM2 BR-18-GXL 3 CAT DATA LINK (-) 43
A367-PT41 GN-18-TEFLON PT-C902
CAN 1 (-) 7 6T-3642
AIR SHUTOFF RELAY DIGITAL SENSOR RETURN 5 998-CM35 BR-18-GXL 101-CM47 RD-10-GXL 893-CM1 GN-18-GXL 4 CAT DATA LINK (+) 44 A368-PT42 BR-18-TEFLON 2407874
EN-C121 A-C1 A-C2 350-0036 24V CAN 2 SHIELD 8 C-T15 45 A369-PT43 PU-18-TEFLON 177-PT4 OR-18-GXL 1 BK-18 SCR LINE HEATER #3
149-C28 PU-14-GXL CKT PROTECTED BATTERY (+) 6 150-CM5 OR-14-GXL 128-CM55 PK-18-GXL Y737-CM14 YL-18-GXL 5 CRS/PRMING PUMP RELAY CONTROL
2610524 2610525 120-A1 YL-16-GXL 2305008 CAN 2 (-) 9 10A DEF DOSING PUMP PWM SUPPLY 46 A364-PT40 YL-18-TEFLON A370-PT44 GY-18-TEFLON K830-PT2 PU-18-TEFLON 2 BK-18 SEE CHART 399-6142 FOR
7 Y738-CM39 GY-18-GXL 6 CRS/PRIMING PUMP RELAY CONTROL RETURN 47
120-EN253 YL-14-TXL 1 120-A1 YL-16-GXL H401-A3 OR-18-GXL H401-A3 OR-18-GXL 1 RD-12 CONT SW SINKING OUTPUT DRIVER RELAY 10
SCR LINE HEATER #3 RETURN 48 K830-PT2 PU-18-TEFLON A371-PT45 PK-18-TEFLON SUCT HTR #3 LINE P/N
CAT DATALINK (+) 8 893-CM1 GN-18-GXL 149-CM28 PU-14-GXL 149-CM46 PU-14-GXL F716-CM43 WH-18-GXL 7 4TH KEY SWITCH POSITION
A250-EN254 BK-14-TXL 2 A250-A2 BK-16-GXL N757-A4 WH-18-GXL G971-A7 BR-16-GXL 2 WH-12 LOAD KEYSWITCH 11 49 C249-PT8 BK-18-TEFLON
CAT DATALINK (-) 9 892-CM2 BR-18-GXL 149-CM31 PU-14-GXL 101-CM47 RD-10-GXL 8 BATTERY (+) TO SMMS 50
OPTIONAL COOLANT LEVEL WIRING H401-EN250 OR-18-GXL 3 H401-A3 OR-18-GXL 119-A11 PK-16-GXL 3 BR-12 + BATTERY BATTERY + 12
CIRCUIT BREAKER 9 A
10 150-CM9 OR-14-GXL 9 A4E4 ECM BATTERY (+) - UNSWITCHED 51
N757-EN106 WH-18-GXL 4 N757-A4 WH-18-GXL N757-A4 WH-18-GXL 4 BK-12 GROUND 6T-3644 C-C8 R 11 150-CM5 OR-14-GXL 150-CM45 OR-14-GXL 301-CM20 BU-10-GXL 10 BATTERY (+) FROM SMMS 52 C250-PT20 BK-14-TXL C250-PT22 BK-12-GXL PT-C916
A250-A2 BK-16-GXL 1552273 53 C250-PT21 BK-14-TXL C250-PT101 BK-16-GXL 2407876
FROM EXTERNAL HARNESS 12 150-CM6 OR-14-GXL 149-CM46 PU-14-GXL 11 HEATED NOZZLE BATTERY (+) - UNSWITCHED 54
ATTACH FOR METRIC TEXT DISPLAY 20A 105-C18 BR-18-GXL 1 13 T788-CM25 GN-12-GXL 12 CRS/PRIMING PUMP LOAD FROM RELAY 55 C250-PT63 BK-14-TXL 177-PT7 OR-18-GXL 1 BK-18 SCR LINE HEATER #1
CONNECTOR EN-C121 START SWITCH 56 C250-PT64 BK-14-TXL N894-PT1 YL-16-TEFLON 2 BK-18 SEE CHART 399-6142 FOR
2 14 150-CM15 OR-14-GXL 150-CM24 OR-14-GXL 150-CM45 OR-14-GXL 13 AFTERTREATMENT ECM UNSWITCHED BATTERY (+)
EN-C800 NC-C1 NC-C2 COOLANT LEVEL SENSOR AIR SHUTOFF BREAKER 255-2752 57
C250-PT65 BK-14-TXL RTN HTR #1 LINE P/N
391-C31 PK-18-GXL 3 15 150-CM23 OR-14-GXL 101-CM26 RD-12-GXL 14 UNSWITCHED BATTERY (+) TO FUEL PUMP CB DEF RTN 58 C254-PT74 BK-18-TEFLON
2407878 2813121 1552267 239-9957 260-3733 24V C OFF PT-C553
ATTACH 20A CIRCUIT BREAKER 150-C38 OR-18-GXL 4 16 150-CM40 OR-14-GXL 308-CM33 YL-18-GXL 15 KEYSWITCH DEF LEVEL SIGNAL 59 H857-PT75 PK-18-TEFLON
A700-EN259 OR-18-GXL 1 A700-NC1 OR-18-GXL A RD-18 +8 VOLTS 6T-3642 12V ON 60 C254-PT74 BK-18-TEFLON 3785571
FOR THE 12V INSTRUMENT GP 107-C34 WH-18-GXL 5 AIR INLET TEMPERATURE SENSOR 17 C829-CM3 GN-18-GXL 101-CM37 RD-10-GXL 16 UNSWITCHED BATTERY (+) TO AFTERTREATMENT ECM /HEATED NOZZLE CB 61
I 998-EN306 BR-18-GXL 998-NC2 BR-18-GXL E740-PT31 GN-18-GXL
I
2 B BK-18 GROUND S ST L929-PT57 BR-18-TEFLON 1 DIV HIGH
6 DIGITAL SENSOR RETURN 18 P967-CM48 PU-18-GXL 150-CM12 OR-14-GXL 150-CM9 OR-14-GXL A244-CM21 BK-14-GXL 17 BATTERY (-) 62
C984-EN292 YL-18-GXL 3 C984-NC3 YL-18-GXL C YL-18 SIGNAL 119-A11 PK-16-GXL 63 COOLANT DIVERTER VALVE
AIR SHUTOFF SOL A5E2 ECM BATTERY (+) 19 150-CM6 OR-14-GXL 150-CM13 OR-14-GXL 101-CM36 RD-14-GXL 18 UNSWITCHED BATTERY (+) A4E4 ECM & KEY SW CB (15A) 2
A250-A2 BK-16-GXL 64 F711-PT69 YL-18-TEFLON 379-8573
267-2170 24V 20 150-CM24 OR-14-GXL 19 A4E4 ECM UNSWITCHED BATTERY (+) DEF DOSING PUMP REV VALVE RTN 65 A368-PT42 BR-18-TEFLON
3
B
213-1626 12V G971-A7 BR-16-GXL 107-C34 WH-18-GXL 21 66 F712-PT70 GN-18-TEFLON L958-PT58 BU-18-TEFLON 4 DIV RETURN
120-A1 YL-16-GXL 22 301-CM20 BU-10-GXL 67 H857-PT75 PK-18-TEFLON
68
C-C6 23 308-CM33 YL-18-GXL 69 J849-PT38 WH-18-TEFLON PT-C906
OPTIONAL AIR SHUTOFF WIRING 2654123 101-C7 RD-14-GXL 24 386-CM30 PK-18-GXL CM-C32 70 K811-PT73 BU-18-TEFLON 3668294
2304011 71 K830-PT2 PU-18-TEFLON 1
A 105-C23 BR-18-GXL 101-C20 RD-14-GXL 101-C41 RD-10-GXL 25 892-CM2 BR-18-GXL 72
B 229-C24 BK-18-GXL C-C1 DEF PURGE LAMP (+) 26 128-CM55 PK-18-GXL 893-CM1 GN-18-GXL C829-CM3 GN-18-GXL 1 73 K837-PT10 BR-18-TEFLON A369-PT43 PU-18-TEFLON 2 PUMP SNSR SUPPLY
CIRCUIT BREAKER 6
2818811
AIR INLET TEMP SENSOR
C 6T-3643 A5E2 ECM BATTERY (-) 27 A244-CM29 BK-14-GXL 998-CM35 BR-18-GXL P967-CM48 PU-18-GXL 2 74 K840-PT54 GY-18-TEFLON A370-PT44 GY-18-TEFLON 3 PUMP SNSR SIGNAL
75 A371-PT45 PK-18-TEFLON 4 PUMP SNSR GND
SERVICE TOOL D 893-C25 GN-18-GXL 150-C2 OR-18-GXL 1 + VS 28 76
C-T13 CM-C800 K900-PT53 YL-18-TEFLON K900-PT72 YL-18-TEFLON 5
CONNECTOR E 892-C26 BR-18-GXL 15A
150-C32 OR-14-GXL 229-C11 BK-18-GXL 2 GND 29 77
F K990-C5 GN-18-GXL K900-C47 YL-18-GXL 3 J1939+ KEYPAD MODULE 30 A244-CM41 BK-4-SGX 2407878 78 K900-PT51 YL-18-TEFLON 6 DEF DOSING PUMP
DEF TEMP SIGNAL 79 K811-PT73 BU-18-TEFLON 7 378-3180
G K900-C39 YL-18-GXL CIRCUIT BREAKER 2 4 SYSTEM WAKEUP 389-9869 31 A244-CM19 BK-14-GXL A700-CM34 OR-18-GXL 1 80
H 6T-3643 105-C17 BR-18-GXL 5 KEY SWITCH A5E2 ECM BATTERY (-) 32 A244-CM32 BK-14-GXL 998-CM35 BR-18-GXL 2 COOLANT LEVEL SENSOR 81 K990-PT46 GN-18-TEFLON K990-PT71 GN-18-TEFLON A366-PT39 BU-18-TEFLON 8 PUMP PWM RETURN
J1939- 82 K990-PT17 GN-18-TEFLON A364-PT40 YL-18-TEFLON 9 PUMP PWM SUPPLY
J 150-C19 OR-14-GXL K990-C36 GN-18-GXL 6 HEATED NOZZLE BATTERY (+) 33 149-CM31 PU-14-GXL A244-CM18 BK-14-GXL C984-CM4 YL-18-GXL 3
83
C-T8 J849-PT38 WH-18-TEFLON 10 PUMP PWM SIGNAL
101-C7 RD-14-GXL 15A GLOBAL CAN A (-) 34 F712-CM50 GN-18-GXL A244-CM42 BK-14-GXL A244-CM16 BK-14-GXL 84
150-C1 OR-18-GXL 35 A244-CM38 BK-12-GXL COOLANT DIVERTER VALVE RTN 85 L958-PT58 BU-18-TEFLON L929-PT57 BR-18-TEFLON A367-PT41 GN-18-TEFLON 11 PUMP REVERSING VALVE
CM-C16 ASO ENABLE SWITCH AND DEF DOSING PUMP REV VALVE 86 A367-PT41 GN-18-TEFLON L930-PT3 YL-16-TEFLON A368-PT42 BR-18-TEFLON 12 PUMP REVERSING VALVE
36 A244-CM54 BK-18-GXL
150-C3 OR-18-GXL CRS/PRIMING PUMP RELAY CONTROL 37 Y737-CM14 YL-18-GXL 2305010 REMOTE SHUTDOWN ARE L958-PT58 BU-18-TEFLON
CIRCUIT BREAKER 4 PT-C903
128-EN6 PK-18-GXL
42 Page,

150-C2 OR-18-GXL 6T-3645 CRS/PRIMING PUMP RELAY CONTROL RTN 38 Y738-CM39 GY-18-GXL 386-CM30 PK-18-GXL 1 CUSTOMER PROVIDED N828-PT32 YL-18-GXL
120-EN253 YL-14-TXL 149-EN71 PU-14-TXL 2407878
24V CRS/PRIMING PUMP RELAY LOAD (+) 39 T788-CM8 GN-14-GXL A244-CM17 BK-14-GXL A244-CM22 BK-14-GXL F716-CM52 WH-18-GXL 2 ASO ENABLE SWITCH/ PT-C28
128-EN6 PK-18-GXL 128-EN6 PK-18-GXL 149-EN103 PU-14-TXL OPTIONAL ATTACHMENT (70 TO 70 ADAPTER HARNESS) 101-C45 RD-12-GXL 101-C200 RD-10-GXL
C-T3
315-C6 GN-10-GXL 40 A244-CM29 BK-14-GXL A244-CM21 BK-14-GXL A244-CM54 BK-18-GXL 3
REMOTE SHUTDOWN/ 3795105 N894-PT1 YL-16-TEFLON H857-PT75 PK-18-TEFLON 1 BK-18 DEF LEVEL
149-EN71 PU-14-TXL 149-EN71 PU-14-TXL 150-EN126 RD-14-TXL 120-PC65 YL-14-GXL C-C11 60A DEF TANK HEADER
CIRCUIT BREAKER 1 41 A244-CM32 BK-14-GXL 128-CM55 PK-18-GXL 4 N895-PT56 PK-18-TEFLON C254-PT74 BK-18-TEFLON 2 BK-18 RETURN
149-EN103 PU-14-TXL 149-EN103 PU-14-TXL 150-EN165 RD-14-TXL 308-PC76 YL-18-GXL 128-PC67 PK-18-GXL 9X1054 DEF LAMP GROUND 1 1 C250-PT63 BK-14-TXL T801-PT33 GY-18-TEFLON K811-PT73 BU-18-TEFLON 3 BK-18 DEF TEMP
389-2651
PC-C2 6T-3643 42 C250-CM56 BK-18-GXL 5
GROUND 2 2 C250-PT21 BK-14-TXL
150-EN126 RD-14-TXL 150-EN49 RD-14-TXL A244-EN161 BK-14-TXL 149-PC20 PU-14-GXL 30 1 150-C22 OR-12-GXL 150-C33 OR-14-GXL 229-C13 BK-18-GXL SOOT SENSOR BATTERY (+) 43 149-CM28 PU-14-GXL A700-CM34 OR-18-GXL 6 GROUND 3 3 C250-PT20 BK-14-TXL
150-EN165 RD-14-TXL 150-EN94 RD-14-TXL A244-EN162 BK-14-TXL 892-PC47 BR-18-GXL 149-PC21 PU-14-GXL 1753366 86 C-T6 1 BK-16 GROUND 4 4 C250-PT64 BK-14-TXL
5 Y738-C27 GY-18-GXL 391-C43 PK-18-GXL REMOTE SHUTDOWN 44 F716-CM53 WH-18-GXL C250-CM56 BK-18-GXL PT-C53
A244-EN161 BK-14-TXL 150-EN95 RD-14-TXL C250-EN14 BK-18-GXL 150-PC14 RD-14-GXL 150-PC14 RD-14-GXL 1 FUEL PUMP RELAY 15A
CM-C6 2 BK-16 GROUND 5 5 C250-PT65 BK-14-TXL 2698222
2 Y737-C15 YL-18-GXL 150-C38 OR-18-GXL 301-C42 BU-10-GXL C-C9 45 C829-CM3 GN-18-GXL POWER IN 1 6 128-PT13 PK-14-TXL
A244-EN162 BK-14-TXL 150-EN96 RD-14-TXL Y737-EN628 YL-18-GXL 893-PC45 GN-18-GXL 150-PC15 RD-14-GXL 120-PC65 YL-14-GXL 2 3E-5239 85 1779646 DEF PURGE LAMP K900-PT72 YL-18-TEFLON
4 T788-C29 GN-12-GXL C984-CM4 YL-18-GXL POWER IN 2 7 128-PT14 PK-14-TXL A

BK-18
BK-18
87 3E3364 46
TERM RESISTOR PT
C250-EN14 BK-18-GXL 150-EN126 RD-14-TXL 308-EN160 YL-18-GXL 150-PC31 RD-14-GXL H416-PC79 GN-18-GXL 3
229-C11 BK-18-GXL 421-5575 POWER IN 3 8 128-PT61 PK-14-TXL K990-PT71 GN-18-TEFLON B

1
2
87a
3 47 T788-CM27 GN-12-GXL 1 RELAY LOAD TO 12V POWER IN 4 9 128-PT62 PK-14-TXL 134-2540
Y737-EN628 YL-18-GXL 150-EN151 RD-14-TXL 892-EN163 BR-18-GXL A244-PC55 BK-14-GXL 150-PC34 RD-14-GXL A700-PC30 OR-18-GXL 4
229-C44 BK-18-GXL A4E4 ECM BATTERY (+) 48 150-CM23 OR-14-GXL A244-CM38 BK-12-GXL 2 10 C
120-EN253 YL-14-TXL 150-EN165 RD-14-TXL 893-EN159 GN-18-GXL 150-PC35 RD-14-GXL 5 FUEL PRIMING PUMP
229-C49 BK-18-GXL COOLANT LEVEL SENSOR 49 C984-CM4 YL-18-GXL F711-CM49 YL-18-GXL F711-CM11 YL-18-GXL CAT CAN A + 11 F711-PT69 YL-18-TEFLON

BK-18
BK-18
A250-EN254 BK-14-TXL 181-EN280 GY-18-GXL F711-EN164 YL-18-GXL F711-PC58 YL-18-GXL 150-PC36 RD-14-GXL 892-PC48 BR-18-GXL 6 CAT CAN A - 12 F712-PT70 GN-18-TEFLON PT-C917
GLOBAL CAN (+) 50 F711-CM49 YL-18-GXL F711-CM44 YL-18-GXL 13
H401-EN250 OR-18-GXL 304-EN261 WH-18-GXL F712-EN116 GN-18-GXL 150-PC102 RD-14-GXL 893-PC46 GN-18-GXL 7 CM-C7 1779649
30 DEF PURGE LAMP RTN 51 C250-CM56 BK-18-GXL CAT CAN C + 14 K900-PT53 YL-18-TEFLON
N757-EN106 WH-18-GXL 308-EN160 YL-18-GXL F712-PC56 GN-18-GXL 181-PC99 GY-18-GXL Y737-PC25 YL-18-GXL 8
86 229-C35 BK-18-GXL A4E4 ECM BATTERY (+) 52 150-CM12 OR-14-GXL F712-CM50 GN-18-GXL F712-CM7 GN-18-GXL 1552267 CAT CAN C - 15 K990-PT46 GN-18-TEFLON 101-PT29 RD-12-GXL 1 BATTERY (+)
998-EN306 BR-18-GXL 308-EN122 YL-18-GXL PC-C800 304-PC78 WH-18-GXL 998-PC50 BR-18-GXL 9 16
229-C13 BK-18-GXL SMMS 12V 101-PT30 RD-12-GXL 2 BATTERY (+)
H H
2407878 FUEL PUMP RELAY 12V A4E4 ECM BATTERY (+) 53 150-CM13 OR-14-GXL F712-CM51 GN-18-GXL F711-CM11 YL-18-GXL A 17
C984-EN292 YL-18-GXL 308-EN157 YL-18-GXL 308-PC76 YL-18-GXL F702-PC41 GN-18-GXL 10 C-T1 241-8367 TERM RES CAN A CM A283-PT23 BK-12-GXL BATTERY (-)
115-1615 85 229-C12 BK-18-GXL 229-C48 BK-14-GXL 54 F712-CM7 GN-18-GXL B 18 3
A700-EN259 OR-18-GXL 381-EN282 PU-18-GXL COOLANT LEVEL 1 A700-PC11 OR-18-GXL 308-PC43 YL-18-GXL 308-PC77 YL-18-GXL G468-PC82 GN-16-GXL 11 134-2540 19 BATTERY (-)
87 229-C24 BK-18-GXL 229-C14 BK-18-GXL A4E4 ECM BATTERY (+) 55 150-CM40 OR-14-GXL F716-CM53 WH-18-GXL F716-CM52 WH-18-GXL C A283-PT25 BK-12-GXL 4
386-EN251 PK-18-GXL SENSOR MATE 2 998-PC49 BR-18-GXL 381-PC101 PU-18-GXL K790-PC44 BU-18-GXL 12 ATTACH 12V SWITCH FOR 20 BEAD FERRITE PT
87a SMMS 56 F716-CM43 WH-18-GXL 21 444-4861
EN-C122 456-EN275 BR-18-GXL TO NC-C1 3 C984-PC109 YL-18-GXL 386-PC5 PK-18-GXL 149-PC20 PU-14-GXL 13 THE 12V INSTRUMENT GP
298-C50 BK-18-GXL A4E4 ECM BATTERY (+) 57 150-CM15 OR-14-GXL 22 128-PT100 PK-16-GXL
2407874 589-EN265 GN-18-GXL 456-PC94 BR-18-GXL 997-PC1 OR-16-GXL 14 241-8368
C-C3 58 23 C250-PT101 BK-16-GXL
AIR INLET TEMP 1 C829-EN635 GN-18-GXL 892-EN163 BR-18-GXL EN-C604 PC-C8 589-PC84 GN-18-GXL 993-PC60 BR-18-GXL 15
1552269 59 P967-CM48 PU-18-GXL 24 E740-PT31 GN-18-GXL
SENSOR 2 993-EN637 BR-18-GXL 892-EN298 BR-18-GXL 2312300 2312295 892-PC47 BR-18-GXL 16 25
ATTACH 12V RELAY FOR 301-C42 BU-10-GXL 60 26 F711-PT69 YL-18-TEFLON
892-EN21 BR-18-GXL K790-EN8 BU-18-GXL 1 K790-PC44 BU-18-GXL 892-PC8 BR-18-GXL 892-PC48 BR-18-GXL F711-PC59 YL-18-GXL 17 391-C46 PK-18-GXL 1 DIODE
EN-C1 THE 12V INSTRUMENT GP A4E4 ECM BATTERY (-) 61 A244-CM17 BK-14-GXL T788-CM8 GN-14-GXL T788-CM27 GN-12-GXL 27 F712-PT70 GN-18-TEFLON
893-EN159 GN-18-GXL H704-EN264 PK-18-GXL 2 H704-PC51 PK-18-GXL 893-PC45 GN-18-GXL F712-PC57 GN-18-GXL 18 229-C14 BK-18-GXL 2 189-3158 28
ECM FUEL COOLED J1 1607689 62 T788-CM25 GN-12-GXL K840-PT54 GY-18-TEFLON
893-EN297 GN-18-GXL A742-EN270 PK-18-GXL 3 A742-PC52 PK-18-GXL 893-PC7 GN-18-GXL 893-PC46 GN-18-GXL M904-PC29 OR-18-GXL 19 29
391-C31 PK-18-GXL A4E4 ECM BATTERY (-) 63 A244-CM18 BK-14-GXL DEF LINE HEATER RELAY HS 30 K837-PT10 BR-18-TEFLON K900-PT51 YL-18-TEFLON
THROTTLE POSITION SENSOR #2 1 X912-EN52 GN-18-GXL 893-EN20 GN-18-GXL J888-EN273 YL-18-GXL 4 J888-PC53 YL-18-GXL 919-PC98 GN-18-GXL 20 391-C43 PK-18-GXL 31 K990-PT17 GN-18-TEFLON
64 Y737-CM14 YL-18-GXL
ANALOG SENSOR POWER (+5V) 2 997-EN1 OR-16-GXL 919-EN279 GN-18-GXL J889-EN274 BR-18-GXL 5 J889-PC61 BR-18-GXL 997-PC1 OR-16-GXL A741-PC103 BU-18-GXL 21 391-C46 PK-18-GXL C-C12 32 N828-PT32 YL-18-GXL
A4E4 ECM BATTERY (-) 65 A244-CM19 BK-14-GXL Y738-CM39 GY-18-GXL 33
ANALOG SENSOR RETURN 3 993-EN2 BR-18-GXL A753-EN276 PU-18-GXL 6 A753-PC62 PU-18-GXL F762-PC9 GY-18-GXL 22 9X1054 66 N895-PT56 PK-18-TEFLON
30 30 34
DIGITAL SENSOR POWER (+8V) 4 A700-EN3 OR-18-GXL 993-EN637 BR-18-GXL 993-EN638 BR-18-GXL P883-EN22 BR-18-GXL 7 P883-PC63 BR-18-GXL 993-PC2 BR-18-GXL 993-PC60 BR-18-GXL Y738-PC26 GY-18-GXL 23 892-C26 BR-18-GXL 229-C44 BK-18-GXL 1 67 35 T801-PT33 GY-18-TEFLON
DIGITAL SENSOR RETURN 5 998-EN7 BR-18-GXL 993-EN2 BR-18-GXL C579-EN269 YL-18-GXL 8 C579-PC64 YL-18-GXL 993-PC54 BR-18-GXL F404-PC18 RD-18-GXL 24 86 86 36
893-C25 GN-18-GXL 107-C34 WH-18-GXL 5
SHUTDOWN RELAY AIR SHUTOFF MANUAL ENABLE 68 386-CM30 PK-18-GXL
FAN REVERSE SWITCH 6 K790-EN8 BU-18-GXL 997-EN1 OR-16-GXL 998-PC4 BR-18-GXL 998-PC50 BR-18-GXL F420-PC19 GN-18-GXL 25 SHUTDOWN RELAY 12V 37
229-C49 BK-18-GXL 2
85 3E-5239 A4E4 ECM BATTERY (-) 69 A244-CM42 BK-14-GXL 38
CRS DISABLE SWITCH 7 P880-EN15 GN-18-GXL 998-EN252 BR-18-GXL EN-C120 PC-C1 998-PC49 BR-18-GXL 308-PC77 YL-18-GXL 26 85 115-1615
K900-C37 YL-18-GXL 298-C50 BK-18-GXL 4 KEYSWITCH 70 308-CM33 YL-18-GXL 39
CAT DATA LINK+ 8 893-EN20 GN-18-GXL 2144208 1607689 A700-PC3 OR-18-GXL A700-PC30 OR-18-GXL F716-PC96 WH-18-GXL 27 87 87 40
K900-C39 YL-18-GXL K900-C8 YL-18-GXL 3
87a DEF LINE HEATER RELAY RTN
CAT DATA LINK- 9 892-EN21 BR-18-GXL 998-EN7 BR-18-GXL X912-EN52 GN-18-GXL 1 X912-PC75 GN-18-GXL A700-PC11 OR-18-GXL 456-PC94 BR-18-GXL 28 87a 41 C249-PT8 BK-18-TEFLON
STARTER RELAY (+) 10 304-EN261 WH-18-GXL 998-EN130 BR-18-GXL 997-EN1 OR-16-GXL 2 997-PC1 OR-16-GXL A741-PC103 BU-18-GXL 381-PC101 PU-18-GXL 29
K900-C47 YL-18-GXL INSTRUMENT PANEL INTERCONNECT WIRING 42
43
ETHER SOLENOID 11 F762-EN44 GY-18-GXL 998-EN256 BR-18-GXL 993-EN638 BR-18-GXL 3 993-PC2 BR-18-GXL A742-PC52 PK-18-GXL C979-PC37 OR-18-GXL 30 K990-C4 GN-18-GXL 44
45
ENGINE MALFUNCTION LAMP 12 H416-EN172 GN-18-GXL 998-EN306 BR-18-GXL A700-EN258 OR-18-GXL 4 A700-PC3 OR-18-GXL A753-PC62 PU-18-GXL 150-PC15 RD-14-GXL 31 K990-C5 GN-18-GXL K990-C9 GN-18-GXL 46
DPF REGENERATION LAMP 13 L471-EN173 BU-18-GXL A244-EN47 BK-14-TXL 998-EN252 BR-18-GXL 5 998-PC4 BR-18-GXL C250-PC68 BK-18-GXL 150-PC34 RD-14-GXL 32 K990-C36 GN-18-GXL ATTACH 12V RELAY FOR 47
ELEK FUEL PUMP MANUAL PRIME SW 14 P899-EN210 YL-16-GXL A244-EN101 BK-14-TXL 150-EN126 RD-14-TXL 6 150-PC14 RD-14-GXL C579-PC64 YL-18-GXL G469-PC10 BU-18-GXL 33 THE 12V INSTRUMENT GP 48
49
AUXILIARY PRESSURE SNSR 15 G469-EN48 BU-18-GXL A244-EN102 BK-14-TXL P880-EN15 GN-18-GXL 7 P880-PC6 GN-18-GXL C979-PC37 OR-18-GXL T788-PC27 GN-14-TXL 34 T788-C29 GN-12-GXL 50
AUXILIARY TEMPERATURE SNSR #1 16 G468-EN263 GN-16-GXL A244-EN153 BK-14-GXL 893-EN297 GN-18-GXL 8 893-PC7 GN-18-GXL C829-PC108 GN-18-GXL 35 Y737-C15 YL-18-GXL 51
C829-EN293 GN-18-GXL A244-EN161 BK-14-TXL 892-EN298 BR-18-GXL 892-PC8 BR-18-GXL C984-PC109 YL-18-GXL 150-PC35 RD-14-GXL DCU KEY SWITCH 52 T801-PT33 GY-18-TEFLON
AIR INLET TEMPERATURE 17 9 36 Y738-C27 GY-18-GXL 53
DIGITAL SENSOR RETURN 18 P967-EN155 PU-18-GXL A244-EN162 BK-14-TXL 304-EN261 WH-18-GXL 10 304-PC78 WH-18-GXL 150-PC31 RD-14-GXL 37
FAN REVERSING SOLENOID 19 H704-EN264 PK-18-GXL A250-EN254 BK-14-TXL F762-EN44 GY-18-GXL 11 F762-PC9 GY-18-GXL E716-PC97 GY-18-GXL A742-PC52 PK-18-GXL 38
EMISSIONS SYSTEM FAIL LAMP 20 M901-EN51 YL-18-GXL H416-EN172 GN-18-GXL 12 H416-PC79 GN-18-GXL E717-PC28 GN-18-GXL G967-PC104 WH-18-GXL 39
AIR SHUTOFF SOL RELAY 21 H401-EN250 OR-18-GXL A700-EN259 OR-18-GXL A700-EN258 OR-18-GXL L471-EN173 BU-18-GXL 13 L471-PC80 BU-18-GXL F404-PC18 RD-18-GXL N765-PC100 PK-18-GXL 40
AC PRESSURE SWITCH 22 589-EN265 GN-18-GXL A700-EN3 OR-18-GXL 120-EN253 YL-14-TXL 14 120-PC65 YL-14-GXL F420-PC19 GN-18-GXL X912-PC75 GN-18-GXL 41
INSTRUMENT PANEL HARNESS
CRS FORCE REGEN SWITCH 23 P878-EN266 GN-18-GXL A741-EN283 BU-18-GXL G469-EN48 BU-18-GXL 15 G469-PC10 BU-18-GXL F702-PC41 GN-18-GXL H704-PC51 PK-18-GXL 42
TDC SERVICE PROBE (+) 24 R723-EN267 PK-18-GXL A742-EN270 PK-18-GXL G468-EN263 GN-16-GXL 16 G468-PC82 GN-16-GXL 149-PC21 PU-14-GXL 43
TDC SERVICE PROBE (-) 25 R724-EN268 PU-18-GXL A753-EN276 PU-18-GXL C829-EN636 GN-18-GXL 17 C829-PC108 GN-18-GXL F711-PC33 YL-18-GXL F711-PC59 YL-18-GXL P967-PC12 PU-18-GXL 44

G G
AUXILIARY TEMPERATURE SNSR #2 26 C579-EN269 YL-18-GXL C250-EN14 BK-18-GXL P967-EN155 PU-18-GXL 18 P967-PC12 PU-18-GXL F711-PC58 YL-18-GXL 304-PC78 WH-18-GXL 45
FLEXXAIRE PITCH #2 27 A742-EN270 PK-18-GXL C579-EN269 YL-18-GXL 150-EN165 RD-14-TXL 19 150-PC15 RD-14-GXL F712-PC24 GN-18-GXL F712-PC57 GN-18-GXL M901-PC13 YL-18-GXL 46
SHUTDOWN (RED) LAMP 28 F404-EN611 RD-18-GXL C979-EN97 OR-18-GXL M901-EN51 YL-18-GXL 20 M901-PC13 YL-18-GXL F712-PC56 GN-18-GXL R723-PC86 PK-18-GXL 47
WARNING (AMBER) LAMP 29 F420-EN166 GN-18-GXL A250-EN254 BK-14-TXL 21 A250-PC66 BK-14-GXL F716-PC96 WH-18-GXL R724-PC87 PU-18-GXL 48
DPF LAMP (SOOT LOADING) 30 P888-EN271 PK-18-GXL C829-EN635 GN-18-GXL C829-EN636 GN-18-GXL 589-EN265 GN-18-GXL 22 589-PC84 GN-18-GXL F762-PC9 GY-18-GXL C579-PC64 YL-18-GXL 49
HEST LAMP 31 P889-EN272 BU-18-GXL C829-EN293 GN-18-GXL P878-EN266 GN-18-GXL 23 P878-PC85 GN-18-GXL G468-PC82 GN-16-GXL 589-PC84 GN-18-GXL 50
PETU 12 V
FAN SPEED (+) 32 J888-EN273 YL-18-GXL C984-EN292 YL-18-GXL C984-EN291 YL-18-GXL R723-EN267 PK-18-GXL 24 R723-PC86 PK-18-GXL G469-PC10 BU-18-GXL J888-PC53 YL-18-GXL 51 DCU PU PU-C27
FAN SPEED (-) 33 J889-EN274 BR-18-GXL C984-EN149 YL-18-GXL R724-EN268 PU-18-GXL 25 R724-PC87 PU-18-GXL G967-PC104 WH-18-GXL J889-PC61 BR-18-GXL 52 378-3181 3795104
PU-C552
CAN A (-) 34 F712-EN152 GN-18-GXL E716-EN278 GY-18-GXL 128-EN6 PK-18-GXL 26 128-PC67 PK-18-GXL H416-PC79 GN-18-GXL A753-PC62 PU-18-GXL 53
9X1054 30
PTO SPEED 1&2 SELECTION 35 456-EN275 BR-18-GXL E717-EN74 GN-18-GXL A244-EN162 BK-14-TXL 27 A244-PC16 BK-14-GXL H704-PC51 PK-18-GXL 919-PC98 GN-18-GXL 54
SCR LINE HEATER #2 RTN 1 L930-PU3 YL-16-TEFLON 101-PU28 RD-12-GXL 1
36 F404-EN611 RD-18-GXL F404-EN611 RD-18-GXL 28 F404-PC18 RD-18-GXL J888-PC53 YL-18-GXL P883-PC63 BR-18-GXL 55 SCR LINE HEATER #1 RTN 2 N894-PU1 YL-16-TEFLON 86
3
N828-PU32 YL-18-GXL 5
MAIN PTU POWER RELAY 12V PU
37 F420-EN166 GN-18-GXL F420-EN166 GN-18-GXL 29 F420-PC19 GN-18-GXL J889-PC61 BR-18-GXL P875-PC106 BU-18-GXL 56
4 101-PU28 RD-12-GXL E740-PU31 GN-18-GXL 2
38 F702-EN627 GN-18-GXL P888-EN271 PK-18-GXL 30 P888-PC90 PK-18-GXL K790-PC44 BU-18-GXL T914-PC105 OR-18-GXL 57 5 85 115-1615
6 101-PU29 RD-12-GXL 187-PU18 PU-12-GXL 4
39 F711-EN164 YL-18-GXL P889-EN272 BU-18-GXL 31 P889-PC91 BU-18-GXL L471-PC80 BU-18-GXL 150-PC36 RD-14-GXL 58 87
7 101-PU30 RD-12-GXL 3
87a
HD JAKE MED/HI SWITCH SELECT 40 E717-EN74 GN-18-GXL F711-EN120 YL-18-GXL A244-EN161 BK-14-TXL 32 A244-PC17 BK-14-GXL M901-PC13 YL-18-GXL P880-PC6 GN-18-GXL 59 COOLANT DIVERTER VALVE HIGH 8 L929-PU57 BR-18-TEFLON
PTO SW/MULTI POSN THRT SW1 41 M904-EN154 OR-18-GXL F711-EN93 YL-18-GXL 149-EN71 PU-14-TXL 33 149-PC20 PU-14-GXL M904-PC29 OR-18-GXL L471-PC80 BU-18-GXL 60 9
10 128-PU13 PK-14-TXL 128-PU12 PK-12-GXL
42 F712-EN116 GN-18-GXL F712-EN117 GN-18-GXL 34 F712-PC24 GN-18-GXL N765-PC100 PK-18-GXL 128-PC67 PK-18-GXL 61 11 128-PU14 PK-14-TXL 128-PU16 PK-12-GXL PU-C547
FAN SOLENOID (+) 43 A753-EN276 PU-18-GXL F712-EN117 GN-18-GXL 456-EN275 BR-18-GXL 35 456-PC94 BR-18-GXL P875-PC106 BU-18-GXL C250-PC68 BK-18-GXL 62 DEF INJECTOR RETURN 12 N895-PU56 PK-18-TEFLON
13 9X1054 30
REMOTE SHUTDOWN SWITCH 44 F716-EN277 WH-18-GXL F712-EN152 GN-18-GXL 229-EN624 BK-14-TXL 36 229-PC22 BK-14-GXL P878-PC85 GN-18-GXL P878-PC85 GN-18-GXL 63
128-EN6 PK-18-GXL 128-EN6 PK-18-GXL 14 128-PU11 PK-12-GXL 1
JAKE LOW HIGH SELECT SW 45 E716-EN278 GY-18-GXL F716-EN277 WH-18-GXL Y737-EN628 YL-18-GXL 37 Y737-PC25 YL-18-GXL P880-PC6 GN-18-GXL P888-PC90 PK-18-GXL 64 15 86
149-EN71 PU-14-TXL 229-EN54 BK-14-TXL 128-PU11 PK-12-GXL C249-PU8 BK-18-TEFLON 5
DEF LINE HEATER RELAY 12V PU
OK TO TAKE CONT ENG SPD REGEN 46 919-EN279 GN-18-GXL F762-EN44 GY-18-GXL Y738-EN105 GY-18-GXL 38 Y738-PC26 GY-18-GXL P883-PC63 BR-18-GXL P889-PC91 BU-18-GXL 65 16
149-EN103 PU-14-TXL 229-EN622 BK-14-TXL DEF DOSING PUMP PRESS SIGNAL 17 A370-PU44 GY-18-TEFLON 128-PU61 PK-14-TXL 128-PU100 PK-16-GXL K837-PU10 BR-18-TEFLON 2
85 115-1615
HSR SPEED LIMIT SWITCH 47 181-EN280 GY-18-GXL G967-EN284 WH-18-GXL T788-EN626 GN-14-TXL 39 T788-PC27 GN-14-TXL P888-PC90 PK-18-GXL E716-PC97 GY-18-GXL 66
DEF DOSING PUMP SENSOR GND
150-EN126 RD-14-TXL A893-EN85 OR-18-GXL 18 A371-PU45 PK-18-TEFLON 128-PU62 PK-14-TXL 177-PU6 OR-12-GXL 4
BATTERY+ 48 150-EN151 RD-14-TXL G468-EN263 GN-16-GXL E717-EN74 GN-18-GXL 40 E717-PC28 GN-18-GXL P889-PC91 BU-18-GXL E717-PC28 GN-18-GXL 67 DEF DOSING PUMP SENSOR SUPPLY 19 A369-PU43 PU-18-TEFLON 87
C250-EN14 BK-18-GXL 3 STARTER P/NS
COOLANT LEVEL SENSOR 49 C984-EN149 YL-18-GXL G469-EN48 BU-18-GXL M904-EN154 OR-18-GXL 41 M904-PC29 OR-18-GXL P967-PC12 PU-18-GXL 181-PC99 GY-18-GXL 68 150-EN165 RD-14-TXL 20 87a
CAN A (+) 308-EN160 YL-18-GXL Y737-EN628 YL-18-GXL 21
50 F711-EN93 YL-18-GXL H704-EN264 PK-18-GXL 229-EN619 BK-14-TXL 42 229-PC23 BK-14-GXL R723-PC86 PK-18-GXL 386-PC5 PK-18-GXL 69 22 PU-C914 DESCRIPTION P/N
FAN SOLENOID (-) 892-EN163 BR-18-GXL Y738-EN608 GY-18-GXL
51 P883-EN22 BR-18-GXL H416-EN172 GN-18-GXL 149-EN103 PU-14-TXL 43 149-PC21 PU-14-GXL R724-PC87 PU-18-GXL 150-PC102 RD-14-GXL 70 23
177-PU4 OR-18-GXL 1779654
893-EN159 GN-18-GXL Y797-EN606 YL-18-GXL DEF DOSING PUMP PWM SIGNAL 24 J849-PU38 WH-18-TEFLON 12V LH P5.0 249-3681
BATTERY (+) 52 150-EN94 RD-14-TXL K790-EN8 BU-18-GXL F716-EN277 WH-18-GXL 44 F716-PC96 WH-18-GXL T788-PC27 GN-14-TXL 177-PU7 OR-18-GXL 187-PU18 PU-12-GXL 1 RD-12 + BAT. INPUT
PC-C3 A244-EN161 BK-14-TXL Y798-EN605 GN-18-GXL 25 11 TEETH ON 12 TOOTH BLANK
BATTERY (+) 53 150-EN95 RD-14-TXL J888-EN273 YL-18-GXL E716-EN278 GY-18-GXL 45 E716-PC97 GY-18-GXL T914-PC105 OR-18-GXL 177-PU5 OR-18-GXL 128-PU12 PK-12-GXL 2 WH-12 + BAT. PUMP VLPM PU
OVERSPEED VERIFY SWITCH 2407874 A244-EN162 BK-14-TXL DEF DOSING PUMP PWM RETURN 26 A366-PU39 BU-18-TEFLON PITCH 6/8
54 N765-EN281 PK-18-GXL J889-EN274 BR-18-GXL 919-EN279 GN-18-GXL 46 919-PC98 GN-18-GXL X912-PC75 GN-18-GXL 27 177-PU6 OR-12-GXL C250-PU22 BK-12-GXL 3 BR-12 GND PUMP 396-6499 12V
1 AIR INLET TEMP C250-EN14 BK-18-GXL 12V LH 42MT 207-1537
BATTERY (+) 55 150-EN96 RD-14-TXL L471-EN173 BU-18-GXL 181-EN280 GY-18-GXL 47 181-PC99 GY-18-GXL Y737-PC25 YL-18-GXL C829-PC108 GN-18-GXL 28
A283-PU24 BK-12-GXL 4 BK-12 GND MACH
PTO ENABLE SW / THROTTLE SW 2 SENSOR F711-EN164 YL-18-GXL 149-EN71 PU-14-TXL 29 11 TEETH ON 12 TOOTH BLANK
56 381-EN282 PU-18-GXL M901-EN51 YL-18-GXL 150-EN151 RD-14-TXL 48 150-PC31 RD-14-GXL Y738-PC26 GY-18-GXL 993-PC54 BR-18-GXL 2
30 187-PU18 PU-12-GXL
BATTERY (+) PC-C7 F712-EN116 GN-18-GXL 149-EN103 PU-14-TXL PITCH: 6/8
57 150-EN49 RD-14-TXL M904-EN154 OR-18-GXL C984-EN291 YL-18-GXL 49 C984-PC109 YL-18-GXL 31
PTO RAMP UP/RES SW/THRTL SW3 8T8736 Y737-EN628 YL-18-GXL 150-EN165 RD-14-TXL DEF INJECTOR SIGNAL 32 K840-PU54 GY-18-TEFLON
58 C979-EN97 OR-18-GXL N757-EN106 WH-18-GXL F711-EN120 YL-18-GXL 50 F711-PC33 YL-18-GXL 12V LH 42MT 6V-4215
GOV MODE SW/INTMD SPEED SW 150-EN126 RD-14-TXL 33
59 A741-EN283 BU-18-GXL C250-EN14 BK-18-GXL 51 C250-PC68 BK-18-GXL 308-PC76 YL-18-GXL A
34 A283-PU24 BK-12-GXL 12 TEETH ON 13 TOOTH BLANK
308-EN160 YL-18-GXL PU-C915
PTO RAMP DOWN/SET SW/THRTL SW4 60 G967-EN284 WH-18-GXL N765-EN281 PK-18-GXL 150-EN94 RD-14-TXL 52 150-PC34 RD-14-GXL A244-PC55 BK-14-GXL B 35 PITCH: 8/10
SERVICE 229-EN54 BK-14-TXL 892-EN163 BR-18-GXL 36 A283-PU23 BK-12-GXL 2407877 SCR LINE HEATER #2 PU
BATTERY (-) 61 A244-EN153 BK-14-GXL P875-EN286 BU-18-GXL 150-EN95 RD-14-TXL 53 150-PC35 RD-14-GXL C
A283-PU25 BK-12-GXL 177-PU5 OR-18-GXL SEE CHART 399-6143 FOR
F F
CONNECTOR 229-EN622 BK-14-TXL 893-EN159 GN-18-GXL 37 1 BK-18 24V LH IMT 293-4853
THROTTLE ARBITRATION SW 62 T914-EN285 OR-18-GXL P878-EN266 GN-18-GXL N765-EN281 PK-18-GXL 54 N765-PC100 PK-18-GXL 893-PC45 GN-18-GXL D 38
A893-EN85 OR-18-GXL A244-EN161 BK-14-TXL L930-PU3 YL-16-TEFLON 2 BK-18 PRESS HTR #2 LINE P/N 11/12 TOOTH PINION
BATTERY (-) 63 A244-EN101 BK-14-TXL P880-EN15 GN-18-GXL 150-EN96 RD-14-TXL 55 150-PC36 RD-14-GXL 892-PC47 BR-18-GXL E 39
Y738-EN608 GY-18-GXL A244-EN162 BK-14-TXL 40 A364-PU40 YL-18-TEFLON PITCH: 6/8
INLET AIR RESTRICTION SW BASED 64 P875-EN286 BU-18-GXL P883-EN22 BR-18-GXL 381-EN282 PU-18-GXL 56 381-PC101 PU-18-GXL F712-PC56 GN-18-GXL F
Y797-EN606 YL-18-GXL F711-EN164 YL-18-GXL 41 A366-PU39 BU-18-TEFLON 24V LH IMT 345-3406
BATTERY (-) 65 A244-EN102 BK-14-TXL P888-EN271 PK-18-GXL 150-EN49 RD-14-TXL 57 150-PC102 RD-14-GXL F711-PC58 YL-18-GXL G 42
Y798-EN605 GN-18-GXL F712-EN116 GN-18-GXL A367-PU41 GN-18-TEFLON 12/13 TOOTH PINION
THROTTLE POSITION SNSR 66 F702-EN627 GN-18-GXL P889-EN272 BU-18-GXL C979-EN97 OR-18-GXL 58 C979-PC37 OR-18-GXL H 43
6

A368-PU42 BR-18-TEFLON PU-C902

50

BATTERY (-) 67 N757-EN106 WH-18-GXL P967-EN155 PU-18-GXL A741-EN283 BU-18-GXL 59 A741-PC103 BU-18-GXL J
44 8/10 PITCH
11

45 A369-PU43 PU-18-TEFLON 2407874

SCR LINE HEATER #3 PU
13

(ENGAGE) ASO RELAY FEEDBACK 68 386-EN251 PK-18-GXL R723-EN267 PK-18-GXL G967-EN284 WH-18-GXL 60 G967-PC104 WH-18-GXL A250-PC66 BK-14-GXL DEF DOSING PUMP PWM SUPPLY 46 A364-PU40 YL-18-TEFLON
47 A370-PU44 GY-18-TEFLON 177-PU4 OR-18-GXL 1 BK-18
BATTERY (-) A244-EN47 BK-14-TXL R724-EN268 PU-18-GXL A244-EN153 BK-14-GXL A244-PC38 BK-14-GXL 229-PC23 BK-14-GXL SEE CHART 399-6142 FOR
4

69 61
9
-T

A371-PU45 PK-18-TEFLON K830-PU2 PU-18-TEFLON

17

SCR LINE HEATER #3 RETURN 48 K830-PU2 PU-18-TEFLON 2 BK-18

KEY SWITCH INPUT 70 308-EN157 YL-18-GXL T914-EN285 OR-18-GXL T914-EN285 OR-18-GXL T914-PC105 OR-18-GXL 229-PC22 BK-14-GXL SUCT HTR #3 LINE P/N
PC

62
8
84

49 C249-PU8 BK-18-TEFLON
49
12

X912-EN52 GN-18-GXL A244-EN101 BK-14-TXL 63 A244-PC39 BK-14-GXL 50

8
11

ALTERNATOR 2
48

51 G S
13

Y737-EN628 YL-18-GXL P875-EN286 BU-18-GXL A244-PC40 BK-14-GXL A244-PC42 BK-10-GXL

3

64 P875-PC106 BU-18-GXL BREAKER 2

11
-M

52 C250-PU20 BK-14-TXL C250-PU22 BK-12-GXL

13

998-EN256 BR-18-GXL A244-EN102 BK-14-TXL A244-PC40 BK-14-GXL A244-PC107 BK-14-GXL

1

ALT
PC

65 53
-T

ECM CHASSIS
C250-PU21 BK-14-TXL C250-PU101 BK-16-GXL PU-C916 MTR BAT
998-EN130 BR-18-GXL P899-EN210 YL-16-GXL F702-EN627 GN-18-GXL F702-PC41 GN-18-GXL A244-PC55 BK-14-GXL 54 CBL-AA1 RD-2-SGX CBL-CC1 RD-2-SGX
2

+ R
PC

66 PJ-C1
-T

1413353 PJ-C7 EN-C601 55 C250-PU63 BK-14-TXL 2407876 SCR LINE HEATER #1 PU

229-EN624 BK-14-TXL 128-PJ6 PK-18-GXL
PC

67 GND
2418834 2814034 56 C250-PU64 BK-14-TXL 177-PU7 OR-18-GXL 1 BK-18
SEE CHART 399-6142 FOR
229-EN619 BK-14-TXL 386-EN251 PK-18-GXL 68 386-PC5 PK-18-GXL A244-PC16 BK-14-GXL A244-PC32 BK-8 DIESEL PARTI FILTER#1 INTAKE TEMP 1 J894-PJ13 WH-18-GXL 128-PJ120 PK-18-GXL 57
2 DEF RTN 58 C254-PU74 BK-18-TEFLON C250-PU65 BK-14-TXL N894-PU1 YL-16-TEFLON 2 BK-18
RTN HTR #1 LINE P/N
MOTOR
T788-EN626 GN-14-TXL A244-EN47 BK-14-TXL 69 A244-PC107 BK-14-GXL A244-PC17 BK-14-GXL 128-PJ110 PK-16-GXL 893-PJ131 GN-18-GXL 1 893-EN159 GN-18-GXL STARTER 2
3 DEF LEVEL SIGNAL 59 H857-PU75 PK-18-TEFLON
Y738-EN105 GY-18-GXL 308-EN122 YL-18-GXL 70 308-PC43 YL-18-GXL A244-PC38 BK-14-GXL TERMINAL POST 128-PJ23 PK-18-GXL 892-PJ68 BR-18-GXL 2 892-EN163 BR-18-GXL 60 PU-C553
4
F712-PJ46 GN-18-GXL C254-PU74 BK-18-TEFLON
A244-PC39 BK-14-GXL BATTERY NEG AFTERTREATMENT #2 ID # MOD RTN 5 P895-PJ89 BU-18-GXL 3 F712-EN116 GN-18-GXL 61 3785571 CBL-AA2 BK-2-SGX
62 E740-PU31 GN-18-GXL
6 149-PJ20 PU-14-GXL F711-PJ28 YL-18-GXL 4 F711-EN164 YL-18-GXL
AFTM #1 FUEL INJ #1 HTR RLY FDBK 7 U799-PJ121 WH-18-GXL 63 L929-PU57 BR-18-TEFLON 1 DIV HIGH
CDL (+) 150-PJ99 RD-14-GXL 5 150-EN126 RD-14-TXL 64
8 893-PJ131 GN-18-GXL F711-PU69 YL-18-TEFLON 2 COOLANT DIVERTER VALVE PU
CDL (-) 9 892-PJ68 BR-18-GXL 150-PJ98 RD-14-GXL 150-PJ98 RD-14-GXL 6 150-EN165 RD-14-TXL DEF DOSING PUMP REV VALVE RTN 65 A368-PU42 BR-18-TEFLON
DCU KEYSWITCH 66 F712-PU70 GN-18-TEFLON 3 379-8575
10 T801-PJ132 GY-18-GXL 150-PJ99 RD-14-GXL A244-PJ130 BK-14-GXL 7 A244-EN162 BK-14-TXL
11 67 H857-PU75 PK-18-TEFLON L958-PU58 BU-18-TEFLON 4 DIV RETURN G S ALTERNATOR 4
308-PJ92 YL-18-GXL A244-PJ96 BK-14-GXL 8 A244-EN161 BK-14-TXL 68 BREAKER 4
AFTM FUEL PUMP RELAY 12 Y737-PJ16 YL-18-GXL 69 J849-PU38 WH-18-TEFLON
13 892-PJ68 BR-18-GXL 149-PJ20 PU-14-GXL 9 149-EN71 PU-14-TXL ALT
70 K811-PU73 BU-18-TEFLON MTR BAT
SCR INLET TEMPERATURE 14 J890-PJ41 BU-18-GXL 893-PJ131 GN-18-GXL 128-PJ6 PK-18-GXL 10 149-EN103 PU-14-TXL 71 CBL-EE1 RD-4-SGX CBL-FF1 RD-4-SGX + R
15 K830-PU2 PU-18-TEFLON
A235-PJ4 BK-18-GXL 128-PJ23 PK-18-GXL 308-PJ92 YL-18-GXL 11 308-EN160 YL-18-GXL 72 GND
16 73 K837-PU10 BR-18-TEFLON 1
A244-PJ96 BK-14-GXL 128-PJ110 PK-16-GXL 12
17 74 K840-PU54 GY-18-TEFLON A369-PU43 PU-18-TEFLON 2 PUMP SNSR SUPPLY MOTOR
DIGITAL RETURN 18 OPTL CUSTOMER INSTL A244-PJ130 BK-14-GXL 128-PJ120 PK-18-GXL 75 STARTER 4
19 PJ-C8 EN-C603 A370-PU44 GY-18-TEFLON 3 PUMP SNSR SIGNAL
A893-PJ124 OR-18-GXL 149-PJ20 PU-14-GXL 76
ARD FUEL FLOW DIVERTER ACTUATOR 20 A893-PJ124 OR-18-GXL 2304009 2606728 77 K900-PU53 YL-18-TEFLON K900-PU72 YL-18-TEFLON A371-PU45 PK-18-TEFLON 4 PUMP SNSR GND
150-PJ98 RD-14-GXL CBL-EE2 BK-4-SGX
21 78 K900-PU51 YL-18-TEFLON 5
SHUTDOWN OVERRIDE SW 22 OPTL CUSTOMER INSTL C250-PJ15 BK-18-GXL 150-PJ99 RD-14-GXL Y797-PJ50 YL-18-GXL 1 Y797-EN606 YL-18-GXL DEF TEMP SIGNAL 79 K811-PU73 BU-18-TEFLON 6 PU-C906 DEF DOSING PUMP PU
23 C250-PJ14 BK-18-GXL 229-PJ19 BK-14-GXL Y798-PJ94 GN-18-GXL 2 Y798-EN605 GN-18-GXL 80 3798453 378-3183
24 81 K990-PU46 GN-18-TEFLON K990-PU71 GN-18-TEFLON 7
C250-PJ101 BK-18-GXL 308-PJ92 YL-18-GXL 128-PJ23 PK-18-GXL 3 128-EN6 PK-18-GXL 82
DIESEL PARTI FILTER#1 INTAKE PRESS 25 J896-PJ9 OR-18-GXL K990-PU17 GN-18-TEFLON A366-PU39 BU-18-TEFLON 8 PUMP PWM RETURN
26 C250-PJ27 BK-18-GXL 892-PJ68 BR-18-GXL C250-PJ27 BK-18-GXL 4 C250-EN14 BK-18-GXL 83
84 A364-PU40 YL-18-TEFLON 9 PUMP PWM SUPPLY
27 893-PJ131 GN-18-GXL 5
28 COOLANT DIVERTER VALVE RTN 85 L958-PU58 BU-18-TEFLON L929-PU57 BR-18-TEFLON J849-PU38 WH-18-TEFLON 10 PUMP PWM SIGNAL

E E
C778-PJ21 BR-18-GXL A244-PJ96 BK-14-GXL Y737-PJ16 YL-18-GXL 6 Y737-EN628 YL-18-GXL DEF DOSING PUMP REV VALVE 86 A367-PU41 GN-18-TEFLON
DCU KEYSWITCH 29 T801-PJ126 GY-18-GXL L930-PU3 YL-16-TEFLON A367-PU41 GN-18-TEFLON 11 PUMP REVERSING VALVE
C800-PJ87 GY-18-GXL A244-PJ130 BK-14-GXL A893-PJ124 OR-18-GXL 7 A893-EN85 OR-18-GXL
30 L958-PU58 BU-18-TEFLON A368-PU42 BR-18-TEFLON 12 PUMP REVERSING VALVE
31 C801-PJ122 OR-18-GXL A893-PJ124 OR-18-GXL 8
N828-PU32 YL-18-GXL
32 E740-PJ48 GN-18-GXL C250-PJ14 BK-18-GXL 9 229-EN622 BK-14-TXL PU-C28 PU-C903
33
CAT CAN A (-) F712-PJ40 GN-18-GXL C250-PJ15 BK-18-GXL 10
3795105 2407878
34 N894-PU1 YL-16-TEFLON
35 F711-PJ72 YL-18-GXL F711-PJ28 YL-18-GXL C250-PJ27 BK-18-GXL 229-PJ19 BK-14-GXL 11 229-EN54 BK-14-TXL
N895-PU56 PK-18-TEFLON H857-PU75 PK-18-TEFLON 1 BK-18 DEF LEVEL
DEF TANK HEADER PU
36 F711-PJ71 YL-18-GXL C250-PJ101 BK-18-GXL Y738-PJ75 GY-18-GXL 12 Y738-EN608 GY-18-GXL GROUND 1 1 C250-PU63 BK-14-TXL
CAT CAN C (+) 37 K900-PJ33 YL-18-GXL T801-PU33 GY-18-TEFLON C254-PU74 BK-18-TEFLON 2 BK-18 RETURN
376-6468
E740-PJ48 GN-18-GXL GROUND 2 2 C250-PU21 BK-14-TXL
CAT CAN C (-) 38 K990-PJ35 GN-18-GXL GROUND 3 3 C250-PU20 BK-14-TXL K811-PU73 BU-18-TEFLON 3 BK-18 DEF TEMP
F712-PJ40 GN-18-GXL F712-PJ47 GN-18-GXL F711-PJ28 YL-18-GXL
39 GROUND 4 4 C250-PU64 BK-14-TXL
40 F712-PJ46 GN-18-GXL F711-PJ71 YL-18-GXL GROUND 5 5 C250-PU65 BK-14-TXL
41 F712-PJ46 GN-18-GXL PJ-C6 PN-C1 PN-C2 PT-C918 POWER IN 1 6 128-PU13 PK-14-TXL
42 2304009 2606728 POWER IN 2 7 128-PU14 PK-14-TXL PU-C53
FL-C2 ARD FUEL PRESS#2 CONT ACTUATOR MAIN 43 C778-PJ21 BR-18-GXL F725-PJ100 WH-18-GXL F712-PJ47 GN-18-GXL 3E5179 1552252 POWER IN 3 8 128-PU61 PK-14-TXL
SECONDARY AND PRIMING 2698222
2304011 44 J890-PJ41 BU-18-GXL K840-PJ26 GY-18-GXL K840-PJ26 GY-18-GXL 1 K840-PN26 GY-18-GXL K840-PN26 GY-18-GXL 1 K840-PT54 GY-18-TEFLON POWER IN 4 9 128-PU62 PK-14-TXL
10 K900-PU72 YL-18-TEFLON A
PUMP FUEL HARNESS F421-FL17 YL-18-GXL 1 SIGNAL FUEL TEMP SENSOR FL
45
46
J894-PJ13 WH-18-GXL K900-PJ79 YL-18-GXL N895-PJ82 PK-18-GXL 2 N895-PN82 PK-18-GXL N895-PN82 PK-18-GXL 2 N895-PT56 PK-18-TEFLON
CAT CAN A + 11 F711-PU69 YL-18-TEFLON K990-PU71 GN-18-TEFLON B TERM RES CAN C PU
FROM ENGINE HARNESS 256-6453 J896-PJ9 OR-18-GXL K900-PJ91 YL-18-GXL K900-PJ79 YL-18-GXL 3 K900-PN79 YL-18-GXL K900-PN79 YL-18-GXL 3 K900-PT51 YL-18-TEFLON CAT CAN A - 12 F712-PU70 GN-18-TEFLON 134-2540
Y749-FL18 GN-18-GXL 2 GROUND AFTERTREATMENT #1 EXH GAS TEMP #1 47 Y743-PJ11 OR-18-GXL C
MATING CONNECTOR BATTERY (+) 48 150-PJ99 RD-14-GXL K840-PJ26 GY-18-GXL K900-PJ136 YL-18-GXL K990-PJ78 GN-18-GXL 4 K990-PN78 GN-18-GXL K990-PN78 GN-18-GXL 4 K990-PT17 GN-18-TEFLON 13
K900-PJ138 YL-18-GXL T801-PJ83 GY-18-GXL 5 T801-PN83 GY-18-GXL T801-PN83 GY-18-GXL 5 T801-PT33 GY-18-TEFLON CAT CAN C + 14 K900-PU53 YL-18-TEFLON
EN-C677 FL-C4 49
CAT CAN C - 15 K990-PU46 GN-18-TEFLON PU-C917
2818804 CAT CAN A (+) 50 F711-PJ72 YL-18-GXL K895-PJ10 BU-18-GXL K990-PJ12 GN-18-GXL 6 6 16 1779649
ARD FUEL PRESS#2 CONTROL ACTUATOR RTN 51 Y736-PJ22 OR-18-GXL K990-PJ78 GN-18-GXL F711-PJ71 YL-18-GXL 7 F711-PN71 YL-18-GXL F711-PN72 YL-18-GXL 7 F711-PT69 YL-18-TEFLON 17
229-FL6 BK-14-GXL G828-FL14 WH-18-GXL 1 + VOLTS 52 150-PJ98 RD-14-GXL 18 101-PU29 RD-12-GXL 1 BATTERY (+)
FL-C1 FUEL PRESS. BEFORE FILTER FL 53 K900-PJ79 YL-18-GXL K990-PJ142 GN-18-GXL F712-PJ47 GN-18-GXL 8 F712-PN47 GN-18-GXL F712-PN50 GN-18-GXL 8 F712-PT70 GN-18-TEFLON 19
A893-FL10 OR-18-GXL Y749-FL11 GN-18-GXL 2 GROUND 101-PU30 RD-12-GXL 2 BATTERY (+)
2304010 320-3060 54 K990-PJ144 GN-18-GXL 128-PJ110 PK-16-GXL 9 128-PN110 PK-16-GXL 128-PN110 PK-16-GXL 9 128-PT100 PK-16-GXL 20
C991-FL15 PK-18-GXL C991-FL15 PK-18-GXL 3 SIGNAL
55 A283-PU23 BK-12-GXL 3 BATTERY (-)
K900-PJ33 YL-18-GXL N828-PJ85 YL-18-GXL C250-PJ101 BK-18-GXL 10 C250-PN101 BK-16-GXL C250-PN101 BK-16-GXL 10 C250-PT101 BK-16-GXL 21
1 G828-FL5 WH-18-GXL F421-FL17 YL-18-GXL 56 22 A283-PU25 BK-12-GXL 4 BATTERY (-)
FL-C7 N895-PJ82 PK-18-GXL E740-PJ48 GN-18-GXL 11 E740-PN48 GN-18-GXL E740-PN48 GN-18-GXL 11 E740-PT31 GN-18-GXL
2 Y749-FL19 GN-18-GXL 57 23
2818804 58 K900-PJ133 YL-18-GXL T801-PJ83 GY-18-GXL N828-PJ85 YL-18-GXL 12 N828-PN85 YL-18-GXL N828-PN85 YL-18-GXL 12 N828-PT32 YL-18-GXL PU-C918
3 G828-FL5 WH-18-GXL G828-FL13 WH-18-GXL DOUT RETURN Y738-PJ75 GY-18-GXL
24
59 Y737-PJ16 YL-18-GXL 25 2606728
4 P792-FL20 BU-18-GXL G828-FL14 WH-18-GXL G828-FL13 WH-18-GXL 1 + VOLTS 60
FUEL PRESS. AFTER FILTER FL AFTERTREATMENT ECM J1 A244-PJ130 BK-14-GXL K900-PJ136 YL-18-GXL Y738-PJ75 GY-18-GXL 26
5 F421-FL17 YL-18-GXL Y749-FL16 GN-18-GXL 2 GROUND 61 27 K840-PU54 GY-18-TEFLON 1
320-3060 62 Y797-PJ3 YL-18-GXL F711-PN71 YL-18-GXL 28
6 P792-FL20 BU-18-GXL P792-FL20 BU-18-GXL 3 SIGNAL N895-PU56 PK-18-TEFLON 2
AFTERTREATMENT ECM J1 63 A244-PJ96 BK-14-GXL Y797-PJ50 YL-18-GXL F711-PN72 YL-18-GXL PN-C3 29
7 A893-FL10 OR-18-GXL T788-FL9 GN-14-GXL 64 K900-PU51 YL-18-TEFLON 3
FL-C6 K900-PJ137 YL-18-GXL K900-PJ91 YL-18-GXL Y798-PJ94 GN-18-GXL F711-PN73 YL-18-GXL 1552267 DEF LINE HEATER RELAY HS 30 K837-PU10 BR-18-TEFLON
8 T788-FL9 GN-14-GXL Y738-FL12 GY-18-GXL 65 31 K990-PU17 GN-18-TEFLON 4
2388245 AFTERTREATMENT #2 ID # MODULE SIGNAL 66 P882-PJ90 YL-18-GXL K900-PJ138 YL-18-GXL Y798-PJ95 GN-18-GXL F712-PN47 GN-18-GXL F711-PN73 YL-18-GXL A
TERM RES CAN A PN 32
9 229-FL6 BK-14-GXL T801-PU33 GY-18-TEFLON 5
CONNECTS TO
ARD FUEL FLOW DIVERTER VALVE FL 67 F712-PN50 GN-18-GXL F712-PN49 GN-18-GXL B 134-2540 33
10 Y749-FL19 GN-18-GXL Y749-FL11 GN-18-GXL A893-FL10 OR-18-GXL 1 GN-18
BEAD FERRITE PU 6
300-3554
68 K990-PJ78 GN-18-GXL F712-PN49 GN-18-GXL C 34 PETU INTERCONNECT
11 C991-FL15 PK-18-GXL Y749-FL16 GN-18-GXL Y738-FL12 GY-18-GXL 2 GN-18 69 35 444-4861 F711-PU69 YL-18-TEFLON 7
12 Y738-FL12 GY-18-GXL Y749-FL18 GN-18-GXL KEYSWITCH 70 308-PJ92 YL-18-GXL 36 F712-PU70 GN-18-TEFLON 8
PN-C2
FL-C5 K990-PJ139 GN-18-GXL PETU INTERCONNECT 37
38 128-PU100 PK-16-GXL 9
PJ-C2 K990-PJ35 GN-18-GXL
2818801 J2 3839081 39 C250-PU101 BK-16-GXL 10
T788-FL9 GN-14-GXL 40

D D
1 ARD AIR PRESS CONTROL VALVE (-) 1 C801-PJ122 OR-18-GXL DEF LINE HEATER RELAY RTN E740-PU31 GN-18-GXL 11
ARD FUEL PUMP FL K990-PJ142 GN-18-GXL 41 C249-PU8 BK-18-TEFLON
229-FL6 BK-14-GXL 2 MOTOR ARD AIR PRESS CONTROL VALVE (+) 2 C800-PJ87 GY-18-GXL 42 N828-PU32 YL-18-GXL 12
344-5192 3 K990-PJ143 GN-18-GXL PJ-C4 43
4 3E3370 44
5 K990-PJ12 GN-18-GXL Y797-PJ3 YL-18-GXL A 45
6 TERM RES CAN B PJ 46
7 K990-PJ144 GN-18-GXL Y798-PJ95 GN-18-GXL B
174-3016 47
8 C 48
9 L944-PJ24 GY-16-GXL 49
10 50
N734-PJ84 YL-18-GXL PJ-C13 51
ECM FUEL COOLED J2 EN-C2
229-EN54 BK-14-TXL
SECONDARY FUEL HARNESS 11
12 1552267 DCU KEY SWITCH 52 T801-PU33 GY-18-TEFLON
2645732 13 N828-PJ17 YL-18-GXL N828-PJ5 YL-18-GXL K900-PJ91 YL-18-GXL A 53
998-EN130 BR-18-GXL 229-EN622 BK-14-TXL TERM RES CAN C PJ
14 N828-PJ85 YL-18-GXL 149-PJ20 PU-14-GXL K990-PJ12 GN-18-GXL B
COMPRESSION BRAKE SOLENOID 1 K738-EN60 GN-16-XLPE 998-EN256 BR-18-GXL A893-EN85 OR-18-GXL 15
134-2540
2
FK-C2 ARD AIR PRESS CONTROL VALVE POSN SNSR 16 N734-PJ84 YL-18-GXL 229-PJ19 BK-14-GXL C
3 Y738-EN608 GY-18-GXL
NRS FLOW BALANCE VALVE ACTUATOR 2304011 17 N895-PJ82 PK-18-GXL A235-PJ4 BK-18-GXL
4 P894-EN34 PU-18-GXL Y797-EN606 YL-18-GXL AFTERTREATMENT #1 ID # MODULE SIGNAL K895-PJ10 BU-18-GXL
EN-C677 FK-C1 FUEL TEMP SENSOR FK
18 C778-PJ21 BR-18-GXL
5 Y798-EN605 GN-18-GXL F421-FK1 YL-18-GXL 1 SIGNAL 19 PJ-C10
2813395 2304010 256-6453 P882-PJ90 YL-18-GXL C800-PJ87 GY-18-GXL
6 Y749-FK2 GN-18-GXL 2 GROUND 20
2305010
7
CAT CAN B (-) 21 Y798-PJ97 GN-18-GXL P895-PJ89 BU-18-GXL C801-PJ122 OR-18-GXL PH-C392 NH-C1 NH-C2
8 G828-EN70 WH-18-GXL 1 G828-FK3 WH-18-GXL C991-FK10 PK-18-GXL 22 R993-PJ52 BR-18-GXL F725-PJ100 WH-18-GXL 128-PJ6 PK-18-GXL 1 VS 2407874 2733288 3684828
9 229-EN624 BK-14-TXL 229-EN624 BK-14-TXL Y749-EN19 GN-18-GXL 2 Y749-FK6 GN-18-GXL F421-FK1 YL-18-GXL 23
FK-C4 R997-PJ51 OR-16-GXL J890-PJ41 BU-18-GXL 2 PLUGGED
10 229-EN619 BK-14-TXL 229-EN619 BK-14-TXL 229-EN602 BK-14-TXL 3 24
AFTM INLET NOX LEVEL SENSOR K840-PH46 GY-18-TEFLON 1 K840-NH1 GY-18-TEFLON 1 DEF INJECTOR (8L)
2818804 AFTERTREATMENT #1 SECONDARY AIR PRESS Y923-PJ31 PU-18-GXL J894-PJ13 WH-18-GXL 3 PLUGGED
J1939 ENGINE CAN B (-) 11 Y798-EN607 GN-18-GXL P899-EN210 YL-16-GXL 229-EN603 BK-14-TXL P792-EN33 BU-18-GXL 4 P792-FK5 BU-18-GXL G828-FK3 WH-18-GXL G828-FK7 WH-18-GXL 25
N895-PH47 PK-18-TEFLON 2 N895-NH2 PK-18-TEFLON 2 362-5344
ARD FUEL PRESSURE #2 (PILOT) 26 F725-PJ100 WH-18-GXL T801-PJ126 GY-18-GXL T801-PJ83 GY-18-GXL J896-PJ9 OR-18-GXL C250-PJ14 BK-18-GXL 4 GND 359-9171
J1939 ENGINE CAN B (+) 12 Y797-EN610 YL-18-GXL T788-EN626 GN-14-TXL 229-EN54 BK-14-TXL F421-EN617 YL-18-GXL 5 F421-FK1 YL-18-GXL G828-FK8 WH-18-GXL G828-FK7 WH-18-GXL 1 + VOLTS DIESEL PARTI FILTER#1 INTAKE PRESS Y777-PJ93 OR-18-GXL
13 FUEL PRESS. BEFORE FILTER FK 27 T801-PJ132 GY-18-GXL K840-PJ26 GY-18-GXL K990-PJ142 GN-18-GXL 5 J1939 (-)
COMPRESSION BRAKE SOLENOID RETURN 14 K739-EN58 BU-16-XLPE Y738-EN105 GY-18-GXL 229-EN622 BK-14-TXL 998-EN256 BR-18-GXL 6 Y749-FK4 GN-18-GXL 2 GROUND 28
320-3060 K895-PJ10 BU-18-GXL K900-PJ136 YL-18-GXL 6 J1939 (+)
INTAKE MANIFOLD PRESSURE SENSOR 15 R746-EN5 PK-18-GXL 994-EN13 GY-18-GXL A893-EN618 OR-18-GXL 7 P792-FK5 BU-18-GXL C991-FK10 PK-18-GXL 3 SIGNAL CAT CAN B (+) 29 Y797-PJ53 YL-18-GXL PH-C683
FUEL PRESSURE SENSOR (BEFORE FILTER) 30 U781-PJ1 YL-16-GXL L944-PJ24 GY-16-GXL 2813134
16 C991-EN609 PK-18-GXL 998-EN130 BR-18-GXL 995-EN46 BU-18-GXL T788-EN601 GN-14-TXL 8
ANALOG RETURN 17
18
G829-EN45 GN-18-GXL 998-EN256 BR-18-GXL 998-EN130 BR-18-GXL
998-EN256 BR-18-GXL
229-EN602 BK-14-TXL
P899-EN631 YL-16-GXL
9
10
Y749-FK6 GN-18-GXL Y749-FK2 GN-18-GXL
Y749-FK4 GN-18-GXL
FK-C3
2818804
31
32
33
U782-PJ2 PK-18-GXL
U798-PJ18 PK-18-GXL
N734-PJ84 YL-18-GXL
N828-PJ5 YL-18-GXL PJ-C11 U781-PH27 YL-18-TEFLON 1
2
+5V
DATA I/O
TIER IV FINAL HARNESSES
U799-PJ121 WH-18-GXL N895-PJ82 PK-18-GXL 2397352
19 A893-EN85 OR-18-GXL C991-EN609 PK-18-GXL 11 C991-FK10 PK-18-GXL Y749-FK9 GN-18-GXL G828-FK8 WH-18-GXL 1 + VOLTS FUEL PRESS. AFTER FILTER FK
ARD FUEL PRESSURE #2 (MAIN) 34 Y747-PJ30 BR-18-GXL K895-PH22 BU-18-TEFLON 3 OUTPUT SIGNAL AFTERTREATMENT #1 ID # MODULE
35 Y733-PJ7 PU-18-GXL P882-PJ90 YL-18-GXL 128-PJ120 PK-18-GXL 1 VS CHG
20 994-EN13 GY-18-GXL A893-EN604 OR-18-GXL Y738-EN201 GY-18-GXL 12 Y749-FK9 GN-18-GXL 2 GROUND 320-3060 A235-PJ4 BK-18-GXL 4 Vpp 342-9070 DESIGNATION DESCRIPTION APPLICATION PART NUMBER
21 995-EN46 BU-18-GXL A893-EN618 OR-18-GXL P792-FK5 BU-18-GXL 3 SIGNAL
AFTERTREATMENT #1 ID # MOD RTN 36 Y734-PJ8 BU-18-GXL P895-PJ89 BU-18-GXL 2 PLUGGED
AFTM OUTLET NOX LEVEL SENSOR 5 CLOCK
LVL
37
Y736-PJ22 OR-18-GXL R993-PJ52 BR-18-GXL 3 PLUGGED
22 C818-EN39 BU-18-GXL C818-EN39 BU-18-GXL 38 359-9172 A235-PH35 BK-18-TEFLON 6 GROUND A AIR SHUTOFF HARNESS PRICE LIST 389-5741 00
EN-C207 39 Y737-PJ16 YL-18-GXL R997-PJ51 OR-16-GXL C250-PJ15 BK-18-GXL 4 GND
23 C819-EN62 PU-18-GXL C819-EN62 PU-18-GXL AA STARTER TO ALTERNATOR PRICE LIST 356-1356 02
2407878 40 Y738-PJ75 GY-18-GXL U781-PJ1 YL-16-GXL K990-PJ144 GN-18-GXL 5 J1939 (-) PH-C227
24 C991-EN609 PK-18-GXL C991-EN609 PK-18-GXL DIGITAL RETURN 41 N828-PJ17 YL-18-GXL POWER + GROUND CABLES
Y743-PJ11 OR-18-GXL U782-PJ2 PK-18-GXL K900-PJ138 YL-18-GXL 6 J1939 (+) 2407878
ENGINE SPEED SENSOR #1 (-) (PRIMARY) 25 E963-EN10 BK-18-GXL E795-EN16 YL-18-GXL E795-EN16 YL-18-GXL Y748-EN83 WH-18-GXL 1 + VOLTS DCU POWER RELAY 42 E740-PJ48 GN-18-GXL
TDC SERVICE PROBE (+) G856-EN11 WH-18-GXL F421-EN617 YL-18-GXL F421-EN617 YL-18-GXL G833-EN77 PK-18-GXL
CRANKCASE PRESS. SENSOR AFT #1 FUEL INJ #1 HEATER RELAY 43 U798-PJ18 PK-18-GXL Y747-PJ30 BR-18-GXL U798-PJ18 PK-18-GXL CC BREAKER TO ALTERNATOR CABLE PRICE LIST 354-8300 01
26 2 GROUND
294-6119 U781-PH30 YL-18-TEFLON 1 + VOLTS ARD FUEL PRESS. #1 (PILOT)
FUEL PRESSURE SENSOR (AFTER FILTER)
44 Y751-PJ25 OR-16-GXL U799-PJ121 WH-18-GXL CM INSTRUMENT PANEL HARNESS PRICE LIST 396-9355 02
27 P792-EN33 BU-18-GXL G828-EN38 WH-18-GXL G828-EN70 WH-18-GXL E795-EN16 YL-18-GXL 3 SIGNAL
SENSOR +5V CEM 45 U781-PJ1 YL-16-GXL U782-PH23 PK-18-TEFLON 2 GROUND 320-3064
ENGINE OIL PRESSURE SENSOR Y777-PJ93 OR-18-GXL Y733-PJ7 PU-18-GXL
28 994-EN13 GY-18-GXL G833-EN28 PK-18-GXL G828-EN88 WH-18-GXL ARD AIR VALVE POSITION +5V 46 R997-PJ51 OR-16-GXL F725-PH15 WH-18-TEFLON 3 SIGNAL CM INSTRUMENT PANEL HARNESS (2.5M) PRICE LIST 397-2766 01
Y734-PJ8 BU-18-GXL
C C
29
ENGINE ANALOG RETURN 30 G833-EN28 PK-18-GXL J808-EN64 BK-18-GXL G828-EN12 WH-18-GXL G828-EN82 WH-16-RADXL EN-C530 47
31 P893-EN9 PU-16-RADXL 2407876 48 Y797-PJ50 YL-18-GXL Y736-PJ22 OR-18-GXL PH-C535 CM INSTRUMENT PANEL HARNESS (4.0M) PRICE LIST 397-2767 01
NRS VALVE ACTUATOR (-) 49 Y797-PJ3 YL-18-GXL Y743-PJ11 OR-18-GXL 2407876 EE STARTER TO ALTERNATOR PRICE LIST 356-1358 01
32 U775-EN30 GY-16-RADXL P894-EN34 PU-18-GXL G828-EN84 WH-16-RADXL C818-EN39 BU-18-GXL 1 FUEL PUMP SOL FORE 1 50 Y797-PJ53 YL-18-GXL Y747-PJ30 BR-18-GXL
CRANKCASE PRESSURE SENSOR 33 E795-EN16 YL-18-GXL P792-EN33 BU-18-GXL G828-EN38 WH-18-GXL C819-EN62 PU-18-GXL 2 326-4352 51 C778-PH9 BR-18-TEFLON 1 RD-16 ARD FUEL #2 CONT ACTUATOR POWER + GROUND CABLES
52 Y798-PJ94 GN-18-GXL Y751-PJ25 OR-16-GXL PH-C536 ARD AIR FLOW CONT ACTUATOR
34 R746-EN5 PK-18-GXL Y736-PH10 OR-18-TEFLON 2 RD-16 344-6590 EN MAIN ENGINE HARNESS (L750 HP) PRICE LIST 438-1116 00
ENGINE SPEED SENSOR #1 (+) (PRIMARY) EN-C531 53 Y798-PJ95 GN-18-GXL Y777-PJ93 OR-18-GXL 2813132 334-8852
35 E964-EN17 WH-18-GXL R747-EN40 GY-18-GXL G833-EN28 PK-18-GXL G833-EN77 PK-18-GXL
TDC SERVICE PROBE (-) 2407876 54 Y798-PJ97 GN-18-GXL Y923-PJ31 PU-18-GXL PH-C228 FC 12 TO 6 PIN INTERCONNECT (2M) PRICE LIST 399-0720 00
36
37
G857-EN18 YL-18-GXL U773-EN37 PK-18-GXL G833-EN26 PK-18-GXL ANALOG SENSOR RETURN CEM 55 U782-PJ2 PK-18-GXL R997-PH7 OR-18-TEFLON 1 +5V
38 U774-EN31 BU-16-RADXL G833-EN615 PK-18-GXL X977-EN620 YL-18-GXL 1 FUEL PUMP SOL AFT 2 FC-C1 ARD AIR VALVE POSITION +5V RETURN 56 R993-PJ52 BR-18-GXL R993-PH40 BR-18-TEFLON 2 SENSOR RETURN 2407879 FC 12 TO 6 PIN INTERCONNECT (4M) PRICE LIST 399-0722 00
NRS DIFFERENTIAL PRESSURE SENSOR
39
326-4352 2304010 57 Y923-PJ31 PU-18-GXL
40 P893-EN9 PU-16-RADXL U775-EN30 GY-16-RADXL J808-EN64 BK-18-GXL X976-EN625 GN-18-GXL 2
58
N734-PH41 YL-18-TEFLON 3 OUTPUT SIGNAL U781-PH36 YL-18-TEFLON 1 + VOLTS
ARD FUEL PRESS. #2 (MAIN) FF BREAKER TO ALTERNATOR CABLE PRICE LIST 354-8298 01
41 U779-EN29 BR-16-RADXL P792-EN33 BU-18-GXL 1 G828-FC1 WH-18-GXL FC-C2 C801-PH39 OR-18-TEFLON 4 POWER PWM (-) U782-PH33 PK-18-TEFLON 2 GROUND
ARD IGN XFMR PRIMARY RTN 59 Y751-PJ25 OR-16-GXL 320-3065 FG 24V PRIMING PUMP HARNESS PRICE LIST 396-6414 00
42 Y748-EN43 WH-18-GXL P893-EN9 PU-16-RADXL 2 Y749-FC2 GN-18-GXL 2305010 ARD IGN XFMR PRIMARY HS 60 L944-PJ24 GY-16-GXL 5 NC Y747-PH3 BR-18-TEFLON 3 SIGNAL
43 Y749-EN86 GN-18-GXL P894-EN34 PU-18-GXL EN-C503 3 G828-FC1 WH-18-GXL 1 61
C800-PH37 GY-18-TEFLON 6 POWER PWM (+) FG 24V PRIMING PUMP HARNESS (2.0M) PRICE LIST 397-2768 00
2407874 62
NRS VALVE ACTUATOR (+) 44 U774-EN31 BU-16-RADXL Y797-EN610 YL-18-GXL 4 P792-FC3 BU-18-GXL Y749-FC2 GN-18-GXL 2 PH-C688 FG 24V PRIMING PUMP HARNESS (4.0M) PRICE LIST 397-2769 00
FROM ENGINE HARNESS CONNECTS TO FUEL HARNESS 63
45 Y798-EN607 GN-18-GXL P899-EN210 YL-16-GXL P899-EN630 YL-16-GXL U774-EN31 BU-16-RADXL 1 RD-18 NRS VALVE ACTUATOR 5 F421-FC4 YL-18-GXL P792-FC3 BU-18-GXL 3 2407878
3420636
MATING CONNECTOR FG-C1 64
FG 24V PRIMING PUMP HARNESS (6.0M) PRICE LIST 397-2770 00
ENGINE SPEED SENSOR #2 (+) (SECONDARY) 46 E966-EN24 YL-18-GXL X976-EN625 GN-18-GXL P899-EN631 YL-16-GXL U775-EN30 GY-16-RADXL 2 RD-18 6 F421-FC4 YL-18-GXL 4 65 L944-PH11 GY-16-TEFLON 1
ENGINE SPEED SENSOR #2 (-) (SECONDARY) EN-C677 OR FN-C1 66
INTERNAL INJECTOR HARNESS ARD IGNITION XFMR PRIMARY FK SECONDARY FUEL JUMPER PRICE LIST 350-3855 01
47 E965-EN25 BU-18-GXL X977-EN620 YL-18-GXL 7 C991-FC5 PK-18-GXL 5 229-PH32 BK-16-TEFLON 2
48
EN-C511 ARD FUEL PRESS#1 CONTROL ACTUATOR 67 Y733-PJ7 PU-18-GXL PH-C687 296-7724
49 R746-EN5 PK-18-GXL 8 6 ARD FUEL PRESS#1 CONTROL ACTUATOR RTN 68 Y734-PJ8 BU-18-GXL WITH BRAKES ARD FUEL NOZZLE HEATER Y751-PH12 OR-16-TEFLON 3 FK SECONDARY FUEL JUMPER PRICE LIST 417-7499 01
FUEL PUMP 2 DRIVER RETURN 50 X976-EN625 GN-18-GXL R747-EN40 GY-18-GXL 2407877 9 69 2407877
GC-C301 FL PRIMARY & SECONDARY FUEL HARNESS PRICE LIST 346-5904 01
51 P894-EN34 PU-18-GXL 1 GN-18 NRS FLOW BAL VALVE ACTR UP 10 70
3754821 GC-C303 OR 1 U799-PH60 WH-14-TEFLON IGNITION CABLE
NRS FLOW BALANCE VALVE ACTR DOUT RTN 52 J808-EN64 BK-18-GXL T788-EN626 GN-14-TXL T788-EN600 GN-14-TXL J808-EN64 BK-18-GXL 2 GN-18 344-6043 11 C991-FC5 PK-18-GXL 2 FN 12V PRIMING PUMP HARNESS PRICE LIST 396-6416 00
T957-GC1 PU-16-NW T957-GC23 PU-16-HF A 3754821
53 T788-EN601 GN-14-TXL 12
GC-C360 T858-GC2 GY-16-NW T858-GC24 GY-16-HF
INJECTOR 1
T959-GC17 BR-16-HF
GC INTERNAL ENGINE HARNESS PRICE LIST 441-4480 00
FUEL RAIL PRESS RETURN EN-C202 B A
INJECTOR 3 ENGINE GROUND
54 G827-EN92 BU-18-GXL U773-EN37 PK-18-GXL 3E3382 W BRAKES
2407879 T859-GC6 WH-16-HF B ARD HEAD GROUND
55 U774-EN31 BU-16-RADXL GC-C302 GM INTERNAL ENGINE HARNESS PRICE LIST 441-4482 00
1 T957-GC1 PU-16-NW
56 U775-EN30 GY-16-RADXL Y748-EN80 WH-18-GXL 1 OR + VOLTS 3754821 GC-C304 149-PH13 PU-14-TEFLON 229-PH31 BK-14-TEFLON SPARK PLUG
57 ENGINE OIL PRESS. SENSOR 2 T958-GC3 YL-16-NW
295-3099
W/O BRAKES
58 U779-EN29 BR-16-RADXL G833-EN26 PK-18-GXL 2 YL GROUND 3754821
274-6719 3 K739-GC13 BU-16-NW T958-GC3 YL-16-NW T958-GC25 YL-16-HF A NC COOLANT LEVEL JUMPER PRICE LIST 387-5401 00
59 X976-EN625 GN-18-GXL 994-EN13 GY-18-GXL 3 GN SIGNAL INJECTOR 2 229-PH20 BK-14-TEFLON 229-PH31 BK-14-TEFLON
4 K738-GC14 GN-16-NW T858-GC4 GY-16-NW T858-GC26 GY-16-HF B T960-GC18 BU-16-HF A CEM GROUND
60 X977-EN620 YL-18-GXL INJECTOR 4 229-PH32 BK-16-TEFLON NH DEF INJECTOR JUMPER PRICE LIST 380-3896 00
EN-C224 5 T859-GC15 WH-16-NW T859-GC8 WH-16-HF B
61 PRIMING PUMP HARNESS 6 T860-GC16 OR-16-NW K738-GC14 GN-16-NW K738-GC21 GN-16-HF PC 70 TO 70 ADAPTER HARNESS PRICE LIST 396-0563 01
NRS TEMPERATURE SENSOR 62 U773-EN37 PK-18-GXL Y738-EN105 GY-18-GXL Y738-EN201 GY-18-GXL 2813120 MATING INJECTOR A235-PH35 BK-18-TEFLON PH-C154 ANALOG FD/DPF INTAKE
CHARGE AIR COOL #1 OUTLET TEMP SENSOR 63 L707-EN98 WH-18-GXL Y738-EN202 GY-18-GXL G828-EN84 WH-16-RADXL 1 + VOLTS
12V ONLY GC-C305
C778-PH9 BR-18-TEFLON 2813125 374-4768 PH COMMERCIAL CEM (G STYLE) PRICE LIST 380-5467 01
64 NRS INTAKE PRESS. SENSOR FN-C4
CONNECTORS K739-GC13 BU-16-NW K739-GC22 BU-16-HF 3754821 RD-18
AFTERTREATMENT #1 GAS TEMP #1
65 Y738-EN608 GY-18-GXL Y749-EN36 GN-16-RADXL 2 GROUND
EN-C3 F725-PH15 WH-18-TEFLON U781-PH26 YL-18-TEFLON 1 VS BK-18 PJ A5E2 HARNESS PRICE LIST 435-9439 00
320-3061 1779646 T961-GC19 GN-16-HF A
66 U779-EN29 BR-16-RADXL 3 SIGNAL ARD FUEL PUMP FN GC-C361 INJECTOR 5 J890-PH43 BU-18-TEFLON U782-PH21 PK-18-TEFLON 2 GND
PN A5E2 TO PETU INTERCONNECT PRICE LIST 385-9184 00
Y748-EN43 WH-18-GXL Y748-EN83 WH-18-GXL MATING TO EXTERNAL T788-FN6 GN-14-GXL
EN-C29 T859-GC15 WH-16-NW T859-GC6 WH-16-HF T860-GC10 OR-16-HF B
67 1 RD-12 MOTOR 348-6959 1552273 J894-PH6 WH-18-TEFLON Y743-PH5 OR-18-TEFLON 3 SIGNAL 1 FLAME
HARNESS (1.5M) (OPTIONAL)
FUEL PUMP 2 DRIVER EN-C200 HARNESS T859-GC8 WH-16-HF
68 X977-EN620 YL-18-GXL Y748-EN89 WH-18-GXL 229-FN7 BK-14-GXL 2 BK-12
GC-C306 J896-PH4 OR-18-TEFLON J894-PH6 WH-18-TEFLON 4 SIGNAL 2 INTAKE RD-18
2813120 1 T961-GC9 GN-16-NW PJ-C12 PH-C686 DPF #1 INTAKE TEMP PN A5E2 TO PETU INTERCONNECT PRICE LIST 385-4842 00
69 Y748-EN80 WH-18-GXL EN-C697 3754821 K840-PH46 GY-18-TEFLON BK-18
2 T962-GC11 WH-16-NW T860-GC16 OR-16-NW T860-GC10 OR-16-HF 3246267 3246266 HARNESS (2.5M) (OPTIONAL)
70 K738-EN60 GN-16-XLPE Y749-EN27 GN-16-RADXL G828-EN88 WH-18-GXL 1 + VOLTS OR FC-C2 K895-PH22 BU-18-TEFLON
B ENGINE LEFT +5V SUPPLY
71
72
73
G828-EN38 WH-18-GXL K739-EN58 BU-16-XLPE
T858-EN56 GY-16-XLPE Y749-EN4 GN-18-GXL
Y749-EN614 GN-18-GXL
Y749-EN616 GN-18-GXL
Y749-EN614 GN-18-GXL
R746-EN5 PK-18-GXL
2
3
GROUND
SIGNAL
INTAKE MANF PRESS. SENSOR
320-3061 FN-C2
3
4
T959-GC5 BR-16-NW
T960-GC7 BU-16-NW
T860-GC12 OR-16-HF T962-GC20 WH-16-HF
T860-GC12 OR-16-HF
A
B
INJECTOR 6 U781-PJ1 YL-16-GXL
U782-PJ2 PK-18-GXL
1
2
U781-PH1 YL-18-TEFLON
U782-PH2 PK-18-TEFLON
L944-PH11 GY-16-TEFLON
N828-PH14 YL-18-TEFLON PH-C155 SCR TEMP INLET
PN A5E2 TO PETU INTERCONNECT
HARNESS (4.0M) (OPTIONAL)
PRICE LIST 385-4841 00 B
NRS INTAKE PRESSURE SENSOR FN-C1 2388245 5 T858-GC4 GY-16-NW T959-GC5 BR-16-NW T959-GC17 BR-16-HF 2813125 373-5283
74 U779-EN29 BR-16-RADXL T859-EN59 WH-16-XLPE Y747-PJ30 BR-18-GXL 3 Y747-PH3 BR-18-TEFLON N895-PH47 PK-18-TEFLON PN A5E2 TO PETU INTERCONNECT PRICE LIST 432-5284 00
75
2397353 ARD FUEL FLOW DIVERTER VALVE FN 6 T858-GC2 GY-16-NW
76 T860-EN57 OR-16-XLPE Y749-EN86 GN-18-GXL A893-FN3 OR-18-GXL 1 GN-18
GC-C374 J896-PJ9 OR-18-GXL 4 J896-PH4 OR-18-TEFLON U781-PH50 YL-18-TEFLON 1 VS
HARNESS (6.0M) (OPTIONAL)
FUEL PUMP 1 DRIVER EN-C225 300-3553 T960-GC7 BU-16-NW T960-GC18 BU-16-HF
77 C818-EN39 BU-18-GXL T957-EN65 PU-16-XLPE Y749-EN19 GN-18-GXL 1 T788-FN6 GN-14-GXL Y738-FN4 GY-18-GXL 2 GN-18 3754821 Y743-PJ11 OR-18-GXL 5 Y743-PH5 OR-18-TEFLON U781-PH18 YL-18-TEFLON U781-PH26 YL-18-TEFLON U782-PH51 PK-18-TEFLON 2 GND RD-18

BAROMETRIC PRESSURE SENSOR 78 R747-EN40 GY-18-GXL T958-EN66 YL-16-XLPE Y749-EN36 GN-16-RADXL 3441666 2 326-FN1 PU-16-GXL J894-PJ13 WH-18-GXL 6 J894-PH6 WH-18-TEFLON U781-PH27 YL-18-TEFLON J890-PH43 BU-18-TEFLON 3 SIGNAL 1 INLET BK-18
SCR TEMP PROBE PT 24V PETU HARNESS PRICE LIST 444-2265 00
T961-GC9 GN-16-NW T961-GC19 GN-16-HF K739-GC22 BU-16-HF A BRAKE ACTUATOR
79 T959-EN73 BR-16-XLPE Y749-EN91 GN-18-GXL G828-EN82 WH-16-RADXL 1 + VOLTS 3 229-FN7 BK-14-GXL 250-9378 Y777-PJ93 OR-18-GXL 7 Y777-PH38 OR-18-TEFLON U781-PH28 YL-18-TEFLON 4 PU 12V PETU HARNESS PRICE LIST 444-2267 00
FUEL RAIL PRESS +5V SUPPLY NRS DIFFERENTIAL PRESS. SENSOR K738-GC21 GN-16-HF B
80 P876-EN42 WH-18-GXL T960-EN612 BU-16-XLPE Y749-EN27 GN-16-RADXL 2 GROUND 4 P899-FN2 YL-16-GXL Y923-PJ31 PU-18-GXL 8 Y923-PH42 PU-18-TEFLON
ENGINE RIGHT +5V SUPPLY 385-1173 FN-C3 T962-GC11 WH-16-NW T962-GC20 WH-16-HF
81 Y748-EN43 WH-18-GXL T961-EN75 GN-16-XLPE Y797-EN610 YL-18-GXL Y797-EN613 YL-18-GXL P893-EN9 PU-16-RADXL 3 SIGNAL 5 A893-FN3 OR-18-GXL N734-PJ84 YL-18-GXL 9 N734-PH41 YL-18-TEFLON U781-PH18 YL-18-TEFLON
82 T962-EN76 WH-16-XLPE Y797-EN606 YL-18-GXL 6 Y738-FN4 GY-18-GXL 1552269 U798-PJ18 PK-18-GXL 10 U798-PH8 PK-18-TEFLON U781-PH1 YL-18-TEFLON
ANALOG RETURN Y749-EN86 GN-18-GXL EN-C203 P899-FN2 YL-16-GXL MANUAL PRIMING SW FN PH-C229
83 1 BK-18 C800-PJ87 GY-18-GXL 11 C800-PH37 GY-18-TEFLON U781-PH29 YL-18-TEFLON
COOLANT TEMPERATURE SENSOR 2813119 284-8381 2813120
84 995-EN46 BU-18-GXL Y798-EN607 GN-18-GXL Y798-EN23 GN-18-GXL 326-FN1 PU-16-GXL 2 BK-18 C801-PJ122 OR-18-GXL 12 C801-PH39 OR-18-TEFLON U781-PH30 YL-18-TEFLON SYMBOL DESCRIPTION ABBREV COLOR (+) BATTERY
FUEL RAIL PRESSURE SENSOR 85 G849-EN623 BR-18-GXL Y798-EN605 GN-18-GXL Y748-EN89 WH-18-GXL 1 + VOLTS L944-PJ24 GY-16-GXL 13 L944-PH11 GY-16-TEFLON U781-PH36 YL-18-TEFLON U781-PH28 YL-18-TEFLON 1 + VOLTS
86
BAROMETRIC PRESS. SENSOR AFTERTREATMENT 1 SEC AIR PRESS
87 G833-EN615 PK-18-GXL 2 GROUND Y751-PJ25 OR-16-GXL 14 Y751-PH12 OR-16-TEFLON U781-PH48 YL-18-TEFLON U782-PH25 PK-18-TEFLON 2 GROUND
320-3062 CIRCUIT CONNECTED RD RED (+) BATTERY SWITCHED
88 R747-EN40 GY-18-GXL 3 SIGNAL 320-3063 C778-PJ21 BR-18-GXL 15 C778-PH9 BR-18-TEFLON U781-PH50 YL-18-TEFLON Y923-PH42 PU-18-TEFLON 3 SIGNAL
89 EN-C204 INJECTOR METER RAIL PRESS. SENSOR Y736-PJ22 OR-18-GXL 16 Y736-PH10 OR-18-TEFLON WH WHITE STARTING CIRCUIT
90 2407878 293-5340 EN-C16 INTERNAL INJECTOR HARNESS U799-PJ121 WH-18-GXL 17 U799-PH61 WH-14-TEFLON PH-C231 CIRCUIT NOT CONNECTED
2813119
91 P876-EN42 WH-18-GXL 1 OR + VOLTS 1552267 WITHOUT BRAKES 149-PJ20 PU-14-GXL 18 149-PH13 PU-14-TEFLON U782-PH19 PK-18-TEFLON U782-PH23 PK-18-TEFLON OR ORANGE (-) BATTERY / SENSOR RETURN
92 G827-EN92 BU-18-GXL 2 YL GROUND Y797-EN613 YL-18-GXL A PRIMING PUMP HARNESS GM-C301 N828-PJ5 YL-18-GXL 19 N828-PH14 YL-18-TEFLON U782-PH24 PK-18-TEFLON U781-PH29 YL-18-TEFLON 1 + VOLTS DPF INTAKE PRESS #1 SENSOR
ELECTRICAL CONNECTION TO
TERM RES CAN B EN MACHINE STRUCTURE
93 G849-EN623 BR-18-GXL 3 GN SIGNAL Y798-EN23 GN-18-GXL B
134-2540 24V ONLY 3754821 F725-PJ100 WH-18-GXL 20 F725-PH15 WH-18-TEFLON U782-PH33 PK-18-TEFLON U782-PH24 PK-18-TEFLON 2 GROUND 330-6719 INTERNAL ELECTRICAL CONNECTION
YL YELLOW
SENSOR / ACTUATOR SUPPLY
94 C
EN-C366 GM-C360 GM-C303 Y733-PJ7 PU-18-GXL 21 Y733-PH16 PU-18-TEFLON U782-PH44 PK-18-TEFLON J896-PH4 OR-18-TEFLON 3 SIGNAL
EN-C400 T957-GM1 PU-16-NW T957-GM23 PU-16-HF A TO SURFACE OF COMPONENT PK PINK
95
1552273 3E3382 INJECTOR 1 3754821 Y734-PJ8 BU-18-GXL 22 Y734-PH17 BU-18-TEFLON
FUEL TEMPERATURE SENSOR 1552269 FG-C5 T858-GM2 GY-16-NW T858-GM24 GY-16-HF B
PH-C539
SIGNAL TO ECM
96 F421-EN617 YL-18-GXL EN-C139 23 U782-PH51 PK-18-TEFLON
2818801 T957-EN65 PU-16-XLPE 1 T957-GM1 PU-16-NW T959-GM17 BR-16-HF A
2610524 CONNECTOR BK BLACK
97 G856-EN11 WH-18-GXL 1 TDC SERVICE 2813115 GM-C302 INJECTOR 3 24 U782-PH21 PK-18-TEFLON CONTROL (POSITIVE) FROM ECM
INJECTOR 5-6 HIGH SIDE
98
ARD FUEL PUMP FG T958-EN66 YL-16-XLPE 2 T958-GM3 YL-16-NW T859-GM6 WH-16-HF B
99 T860-EN57 OR-16-XLPE G857-EN18 YL-18-GXL 2
PROBE U773-EN37 PK-18-GXL 1 BK-18 SIGNAL NRS TEMP SENSOR T788-FG6 GN-14-GXL 1 RD-12 MOTOR 3754821 229-PJ19 BK-14-GXL 25 229-PH20 BK-14-TEFLON U782-PH19 PK-18-TEFLON U782-PH25 PK-18-TEFLON U798-PH8 PK-18-TEFLON 1 RD-12 CONT SW CONTROL (RETURN) FROM ECM
344-5192 K739-EN58 BU-16-XLPE 3
ARD FUEL NOZZLE HEATER RELAY H# GY GRAY
100 Y749-EN91 GN-18-GXL 2 BK-18 GROUND 339-8822 229-FG7 BK-14-GXL 2 BK-12
GM-C304 R993-PJ52 BR-18-GXL 26 R993-PH40 BR-18-TEFLON U782-PH2 PK-18-TEFLON U799-PH34 WH-14-TEFLON 2 WH-12 LOAD CIRCUIT GROUPING DESIGNATION
EN-C146 CHARGE AIR COOLER OUTLET TEMP K738-EN60 GN-16-XLPE 4 T958-GM3 YL-16-NW T958-GM25 YL-16-HF A
312-1080 24V CAT DATA LINK
101 INJECTOR 2 3754821 K895-PJ10 BU-18-GXL 27 K895-PH22 BU-18-TEFLON 149-PH13 PU-14-TEFLON 3 BR-12 + BATTERY PU PURPLE
2407874 256-6453 EN-C100 T859-EN59 WH-16-XLPE 5 T859-GM15 WH-16-NW T858-GM4 GY-16-NW T858-GM26 GY-16-HF B
102 A235-PJ4 BK-18-GXL 28 A235-PH35 BK-18-TEFLON U798-PH8 PK-18-TEFLON N828-PH14 YL-18-TEFLON 4 BK-12 GROUND ATCH WIRE, CABLE, COMPONENT
2407874 T860-EN57 OR-16-XLPE 6 T860-GM16 OR-16-NW T960-GM18 BU-16-HF A J1939 DATA LINK
103 L707-EN98 WH-18-GXL 1 SIGNAL INJECTOR 4 J890-PJ41 BU-18-GXL 29 J890-PH43 BU-18-TEFLON BR BROWN
INJECTOR 1-2 HIGH SIDE COOLANT TEMP SENSOR FG-C4 T859-GM8 WH-16-HF B
PH-C534
104 T858-EN56 GY-16-XLPE G829-EN45 GN-18-GXL 2 GROUND 995-EN46 BU-18-GXL 1 SIGNAL 30 U799-PH61 WH-14-TEFLON U799-PH34 WH-14-TEFLON SPLICE
INJECTOR 6 RETURN T962-EN76 WH-16-XLPE Y749-EN616 GN-18-GXL 256-6453 EN-C697 FG-C1 2388245 2407876 RS-232/RS-485 DATA LINK
105 2 GROUND GM-C305 K840-PJ26 GY-18-GXL 31 K840-PH46 GY-18-TEFLON U799-PH60 WH-14-TEFLON GN GREEN
INJECTOR 3 RETURN 106 T959-EN73 BR-16-XLPE 2813133 2397353 A893-FG9 OR-18-GXL 1 GN-18 ARD FUEL FLOW DIVERTER VALVE FG N895-PJ82 PK-18-GXL 32 N895-PH47 PK-18-TEFLON Y733-PH16 PU-18-TEFLON 1 RD-16 ARD FUEL #1 CONT ACTUATOR
EN-C371 GM-C361 3754821 BLADE, SPADE, RING OR SCREW
INJECTOR 5 RETURN 107 T961-EN75 GN-16-XLPE EN-C417 TOP SPEED/TIMING "A" RUN T788-EN600 GN-14-TXL 1 T788-FG6 GN-14-GXL Y738-FG10 GY-18-GXL 2 GN-18 300-3554 R997-PJ51 OR-16-GXL 33 R997-PH7 OR-18-TEFLON Y733-PH16 PU-18-TEFLON Y734-PH17 BU-18-TEFLON 2 RD-16 344-6590 BU BLUE HIGHWAYS
3E3382 1552273 T961-GM19 GN-16-HF A
TERMINAL
INJECTOR 4 RETURN 108 T960-EN612 BU-16-XLPE 1003320 109-7194 998-EN130 BR-18-GXL 2 326-FG11 PU-16-GXL INJECTOR 5 34 Y734-PH17 BU-18-TEFLON
T961-EN75 GN-16-XLPE 1 T961-GM9 GN-16-NW T859-GM15 WH-16-NW T859-GM6 WH-16-HF T860-GM10 OR-16-HF B
109 E965-EN25 BU-18-GXL A 229-EN603 BK-14-TXL 3 229-FG7 BK-14-GXL 35 Y736-PH10 OR-18-TEFLON
T962-EN76 WH-16-XLPE 2 T962-GM11 WH-16-NW T859-GM8 WH-16-HF
A A
110 E966-EN24 YL-18-GXL B P899-EN630 YL-16-GXL 4 P899-FG8 YL-16-GXL FG-C6 36 Y743-PH5 OR-18-TEFLON PH-C230
T959-EN73 BR-16-XLPE 3 T959-GM5 BR-16-NW GM-C306
FUEL PUMP 1 DRIVER RETURN 111 C819-EN62 PU-18-GXL A893-EN604 OR-18-GXL 5 A893-FG9 OR-18-GXL 1552269 37 Y747-PH3 BR-18-TEFLON 2407878
112 T960-EN612 BU-16-XLPE 4 T960-GM7 BU-16-NW T860-GM16 OR-16-NW T860-GM10 OR-16-HF 3754821
113 EN-C419 BOTTOM SPEED/TIMING "B" CRANKING Y738-EN202 GY-18-GXL 6 Y738-FG10 GY-18-GXL P899-FG8 YL-16-GXL 1 BK-18 MANUAL PRIMING SW FG 38 Y751-PH12 OR-16-TEFLON U781-PH48 YL-18-TEFLON 1 + VOLTS
INJECTOR 3-4 HIGH SIDE
114 1112416 109-7195 284-8381 T858-EN621 GY-16-XLPE 5 T858-GM4 GY-16-NW T860-GM12 OR-16-HF T962-GM20 WH-16-HF A DPF DELTA PRESS.
115 T859-EN59 WH-16-XLPE 326-FG11 PU-16-GXL 2 BK-18 INJECTOR 6 P882-PJ90 YL-18-GXL 39 Y777-PH38 OR-18-TEFLON U782-PH44 PK-18-TEFLON 2 GROUND
INJECTOR 1 RETURN 116
117
T957-EN65 PU-16-XLPE E963-EN10 BK-18-GXL A
T858-EN56 GY-16-XLPE T858-EN72 GY-16-XLPE 6 T858-GM2 GY-16-NW
T959-GM5 BR-16-NW T959-GM17 BR-16-HF
T860-GM12 OR-16-HF B
P895-PJ89 BU-18-GXL 40 Y923-PH42 PU-18-TEFLON Y777-PH38 OR-18-TEFLON 3 SIGNAL
294-6118 THIS SCHEMATIC IS FOR THE C9.3 INDUSTRIAL ENGINE ELECTRICAL SYSTEM
INJECTOR 2 RETURN 118 T958-EN66 YL-16-XLPE E964-EN17 WH-18-GXL B
119
120 245-4630
T960-GM7 BU-16-NW T960-GM18 BU-16-HF VOLUME 1 of 2: CUSTOMER INTERCONNECT HARNESS
T961-GM9 GN-16-NW T961-GM19 GN-16-HF MEDIA NUMBER: UENR4683-03
T962-GM11 WH-16-NW T962-GM20 WH-16-HF
SCHEMATIC PART NUMBER: 397-8696, CHANGE: 02, VERSION: -
Components are shown installed on a fully operable engine in a non powered state.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
 UENR4683-03
July 2017 Harness And Wire Electrical Schematic Symbols
COOLANT DIVERTER Symbols
VALVE
T

Pressure Temperature Level Flow Circuit Breaker

Symbol Symbol Symbol Symbol Symbol

Symbols and Definitions

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.

DEF LINE Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.

HEATER RELAY Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.

MAIN PTU Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.

POWER RELAY Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
DEF DOSING PUMP
C9.3 Industrial Engine contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

DIESEL EXHAUST MODULE RIGHT VIEW Electrical System T

Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.

CS91-UP Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.

DCU Solenoid: A solenoid is an electrical component that is activated by electricity. It has a

coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is

activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.

Harness and Wire Symbols

Wire, Cable, or Harness Harness Identification Letter(s):
Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
Harness Identification Letters and
Harness Connector Serialization Code:
Harness Connector Serialization
The "C" stands for "Connector" and the
Codes (see sample).
number indicates which connector in the
AG-C4 L-C12 harness (C1, C2, C3, ...).
L-C12
111-7898 3E-5179
VLPM Part Number: for Connector Plug 1
3E-5179
Part Number: for Connector Receptacle
2
Plug Receptacle
Pin or Socket Number
5A
1 Deutsch connector: Typical representation
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
2 sockets and the receptacle contains all pins.
Volume 2 of 2: DEF Tank Wiring
DIESEL EXHAUST MODULE LEFT VIEW 1 Sure-Seal connector: Typical representation
of a Sure-Seal connector. The plug and receptacle
Harness identification code:
This example indicates wire group 325,
325-AG135 PK-14
Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color

© 2017 Caterpillar CAT, CATERPILLAR, their respective logos, “Caterpillar Yellow”, and the POWER EDGE trade dress as well as
All Rights Reserved corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.

PV-C917, PU-C917

PV-C918, PU-C918

TERM RES CAN C

CONNECT TO
SCR LINE HEATER#2

UENR4683-03 VOL 2 of 2
(Dimensions: 34 inches x 28 inches)
DIESEL EXHAUST MODULE FRONT VIEW

SCR LINE HEATER #1

DEF TANK HEADER

24 Page,
SCR LINE HEATER #3

DIESEL EXHAUST MODULE TOP VIEW

 7 6 5 4 3 2 1

PETU 12V HEADER W/QUALITY SENSOR PETU 24V HEADER W/QUALITY SENSOR
(IF EQUIPPED) PU-C552
(IF EQUIPPED) PV-C552
9X1054 30
9X1054 30 101-PV39 RD-12-GXL 1
101-PU39 RD-12-GXL 1 86
86 N828-PV57 YL-18-GXL 5
N828-PU57 YL-18-GXL 5 MAIN PTU POWER RELAY 24V 2
MAIN PTU POWER RELAY 12V E740-PV52 GN-18-GXL 2
85
E740-PU52 GN-18-GXL 2 3E-5239
85 115-1615 187-PV46 PU-12-GXL 4
187-PU46 PU-12-GXL 4 87
87 3
87a
3
F 87a F

PU-C547 PV-C547
9X1054 9X1054 30
30 128-PV37 PK-12-GXL 1
128-PU37 PK-12-GXL 1
86
86 C249-PV33 BK-18-PTFE 5
C249-PU33 BK-18-PTFE 5
DEF LINE HEATER RELAY 24V 2
K837-PU32 BR-18-PTFE 2 DEF LINE HEATER RELAY 12V K837-PV32 BR-18-PTFE 2
85 115-1615 85 3E-5239
177-PU42 OR-12-GXL 4 177-PV42 OR-12-GXL 4
87
87 3
3 87a
87a

PV-C914
1779654
PU-C914 187-PV46 PU-12-GXL 1 RD-12 + BAT. INPUT
1779654 128-PV36 PK-12-GXL 2 WH-12 + BAT. PUMP VLPM 2
187-PU46 PU-12-GXL 1 RD-12 + BAT. INPUT
C250-PV50 BK-12-GXL 3 BR-12 GND PUMP 396-6500 24V
128-PU36 PK-12-GXL 2 WH-12 + BAT. PUMP VLPM PW A283-PV47 BK-12-GXL 4 BK-12 GND MACH
C250-PU50 BK-12-GXL 3 BR-12 GND PUMP 396-6500 24V
A283-PU47 BK-12-GXL 4 BK-12 GND MACH

PV-C915
2407877 SCR LINE HEATER #2 2
177-PV43 OR-18-GXL 1 BK-18 SEE CHART 399-6143 FOR
PU-C915 L930-PV1 YL-16-PTFE 2 BK-18 PRESS HTR #2 LINE P/N
2407877
177-PU43 OR-18-GXL 1 BK-18 SCR LINE HEATER #2 PW
L930-PU1 YL-16-PTFE 2 BK-18 SEE CHART 399-6143 FOR
DCU PU PU-C27 PRESS HTR #2 LINE P/N DCU 2 PV-C27
373-5577 3795104 373-5577 3795104
1 L930-PU1 YL-16-PTFE 1 L930-PV1 YL-16-PTFE PV-C902
2 N894-PU2 YL-16-PTFE 2 N894-PV2 YL-16-PTFE 2407874 SCR LINE HEATER #3 2
3 3 177-PV45 OR-18-GXL 1 BK-18 SEE CHART 399-6142 FOR
4 4 K830-PV12 PU-18-PTFE 2 BK-18 SUCT HTR #3 LINE P/N
PU-C902 5
E 5
6
2407874
SCR LINE HEATER #3 PW
6
7
E
7
8 L929-PU3 BR-18-PTFE 177-PU45 OR-18-GXL 1 BK-18 8 L929-PV3 BR-18-PTFE
9 K830-PU12 PU-18-PTFE 2 BK-18 SEE CHART 399-6142 FOR 9
10
10
11 SUCT HTR #3 LINE P/N DEF INJECTOR RETURN
11
N895-PV4 PK-18-PTFE
DEF INJECTOR RETURN 12 N895-PU4 PK-18-PTFE 12
13
14
13
14 PV-C916
15 15 2407876 SCR LINE HEATER #1 2
16
DEF DOSING PUMP PRESS SIG
16
17 A370-PU5 GY-18-PTFE DEF DOSING PUMP PRESS SIG 17 A370-PV5 GY-18-PTFE 101-PV39 RD-12-GXL 177-PV44 OR-18-GXL 1 BK-18 SEE CHART 399-6142 FOR
DEF DOSING PUMP SENSOR GND 18 A371-PU6 PK-18-PTFE DEF DOSING PUMP SENSOR GND 18 A371-PV6 PK-18-PTFE 101-PV40 RD-12-GXL N894-PV2 YL-16-PTFE 2 BK-18 RTN HTR #1 LINE P/N
DEF DOSING PUMP SNSR SUPPLY A369-PU7 PU-18-PTFE 101-PU39 RD-12-GXL DEF DOSING PUMP SNSR SUPPLY 19 A369-PV7 PU-18-PTFE
19 101-PV41 RD-12-GXL
20 101-PU40 RD-12-GXL PU-C916 20
21
101-PU41 RD-12-GXL
21
22 128-PV58 PK-18-PTFE
22
23
2407876 23 128-PV24 PK-14-TXL 128-PV36 PK-12-GXL
DEF DOSING PUMP PWM SIGNAL J849-PU8 WH-18-PTFE 128-PU58 PK-18-PTFE 177-PU44 OR-18-GXL 1 BK-18 SCR LINE HEATER #1 PW DEF DOSING PUMP PWM SIGNAL 24 J849-PV8 WH-18-PTFE PV-C553
24 128-PV25 PK-14-TXL 128-PV35 PK-12-GXL
25 128-PU24 PK-14-TXL 128-PU36 PK-12-GXL N894-PU2 YL-16-PTFE 2 BK-18 SEE CHART 399-6142 FOR 25
3785571
DEF DOSING PUMP PWM RETURN 26 A366-PU9 BU-18-PTFE 128-PU25 PK-14-TXL 128-PU35 PK-12-GXL RTN HTR #1 LINE P/N DEF DOSING PUMP PWM RETURN 26 A366-PV9 BU-18-PTFE L929-PV3 BR-18-PTFE 1 DIV HIGH
27
27
28 28 128-PV37 PK-12-GXL 2 COOLANT DIVERTER VALVE 2
29
29
30 128-PV26 PK-14-TXL 128-PV38 PK-16-GXL 3 379-8573
30 128-PU37 PK-12-GXL L958-PV17 BU-18-PTFE 4 DIV RETURN
31 31 128-PV27 PK-14-TXL
DEF INJECTOR SIGNAL K840-PU10 GY-18-PTFE 128-PU26 PK-14-TXL 128-PU38 PK-16-GXL DEF INJECTOR SIGNAL 32 K840-PV10 GY-18-PTFE
32
128-PU27 PK-14-TXL PU-C553
33
33
34 3785571 34
35
35
36 L929-PU3 BR-18-PTFE 1 DIV HIGH 36 177-PV45 OR-18-GXL
37
2 COOLANT DIVERTER VALVE PW 37
38 177-PV44 OR-18-GXL PV-C906
38
177-PU45 OR-18-GXL 39 3668294
39
3 379-8573 40 177-PV43 OR-18-GXL
40
177-PU44 OR-18-GXL 41 1
41
L958-PU17 BU-18-PTFE 4 DIV RETURN 42 177-PV42 OR-12-GXL
42
43 177-PU43 OR-18-GXL 43 A369-PV7 PU-18-PTFE 2 PUMP SNSR SUPPLY
44
44
177-PU42 OR-12-GXL 45 A370-PV5 GY-18-PTFE 3 PUMP SNSR SIGNAL
45
187-PV46 PU-12-GXL
DEF DOSING PUMP PWM SUPPLY 46 A364-PU11 YL-18-PTFE DEF DOSING PUMP PWM SUPPLY 46 A364-PV11 YL-18-PTFE A371-PV6 PK-18-PTFE 4 PUMP SNSR GND
47 187-PU46 PU-12-GXL 47 5
48 K830-PU12 PU-18-PTFE PU-C906 48
49
K830-PV12 PU-18-PTFE A283-PV47 BK-12-GXL 6
DEF DOSING PUMP 2
49
50 3798453 50
51 A283-PV48 BK-12-GXL 7 485-9753
51
A283-PU47 BK-12-GXL 1 52 A366-PV9 BU-18-PTFE 8 PUMP PWM RETURN
52
53 A283-PV49 BK-12-GXL
53
54 A283-PU48 BK-12-GXL A369-PU7 PU-18-PTFE 2 PUMP SNSR SUPPLY 54 A364-PV11 YL-18-PTFE 9 PUMP PWM SUPPLY
55
55
A283-PU49 BK-12-GXL A370-PU5 GY-18-PTFE 3 PUMP SNSR SIGNAL 56 J849-PV8 WH-18-PTFE 10 PUMP PWM SIGNAL
56
57 A364-PV11 YL-18-PTFE
DEF RTN
57
C254-PU13 BK-18-PTFE A371-PU6 PK-18-PTFE 4 PUMP SNSR GND DEF RTN 58 C254-PV13 BK-18-PTFE A367-PV18 GN-18-PTFE 11 PUMP REVERSING VALVE
58 A366-PV9 BU-18-PTFE
DEF LEVEL SIGNAL A364-PU11 YL-18-PTFE 5 DEF LEVEL SIGNAL 59 A368-PV15 BR-18-PTFE 12 PUMP REVERSING VALVE
59
60 A367-PV18 GN-18-PTFE
60
A366-PU9 BU-18-PTFE 6 DEF DOSING PUMP PW 61
61
62 A368-PV15 BR-18-PTFE
62
A367-PU18 GN-18-PTFE 7 3984746 63
63
64 A369-PV7 PU-18-PTFE
DEF DOSING PUMP REV VALVE
64
A368-PU15 BR-18-PTFE A368-PU15 BR-18-PTFE A366-PU9 BU-18-PTFE 8 PUMP PWM RETURN DEF DOSING PUMP REV VALVE 65 A368-PV15 BR-18-PTFE
65 A370-PV5 GY-18-PTFE
66 A369-PU7 PU-18-PTFE A364-PU11 YL-18-PTFE 9 PUMP PWM SUPPLY
66
67 A371-PV6 PK-18-PTFE PV-C903
67
A370-PU5 GY-18-PTFE J849-PU8 WH-18-PTFE 10 PUMP PWM SIGNAL 68
68 C249-PV33 BK-18-PTFE 1762946
D 69
70
71
A371-PU6 PK-18-PTFE
C249-PU33 BK-18-PTFE
A367-PU18 GN-18-PTFE 11 PUMP REVERSING VALVE
69
70
71 K900-PV16 YL-18-PTFE 1 WH-20 CAN H D
72 A368-PU15 BR-18-PTFE 12 PUMP REVERSING VALVE 72
73 C250-PV21 BK-14-TXL C250-PV50 BK-12-GXL K990-PV14 GN-18-PTFE 2 BR-20 CAN L DEF TANK HEADER 2
73
74
74
75 C250-PV20 BK-14-TXL C250-PV51 BK-16-GXL 128-PV58 PK-18-PTFE 3 RD-20 B+ 499-6590
75
C250-PU21 BK-14-TXL C250-PU50 BK-12-GXL 76
76 C250-PV19 BK-14-TXL C254-PV13 BK-18-PTFE 4 BK-20 GROUND
77 C250-PU20 BK-14-TXL C250-PU51 BK-16-GXL 77
78 78 C250-PV22 BK-14-TXL
DEF TEMP SIGNAL C250-PU19 BK-14-TXL DEF TEMP SIGNAL 79
79
80 C250-PV23 BK-14-TXL
80
81 C250-PU22 BK-14-TXL 81
82
82
C250-PU23 BK-14-TXL PU-C903 83
83
84 C254-PV13 BK-18-PTFE
84
85 L958-PU17 BU-18-PTFE 1762946 85 L958-PV17 BU-18-PTFE E740-PV52 GN-18-GXL
DEF DOSING PUMP REV VALVE 86 A367-PU18 GN-18-PTFE C254-PU13 BK-18-PTFE K900-PU16 YL-18-PTFE 1 WH-20 CAN H DEF DOSING PUMP REV VALVE 86 A367-PV18 GN-18-PTFE
E740-PU52 GN-18-GXL K990-PU14 GN-18-PTFE 2 BR-20 CAN L DEF TANK HEADER PW PY-C1
PU-C28 PV-C28 F711-PV28 YL-18-PTFE PY-C2
128-PU58 PK-18-PTFE 3 RD-20 B+ 499-6590 1519277
3795105 3795105 F712-PV29 GN-18-PTFE 1762946
F711-PU28 YL-18-PTFE C254-PU13 BK-18-PTFE 4 BK-20 GROUND
1 K900-PY1 YL-18-PTFE 1
GROUND 1 C250-PU19 BK-14-TXL F712-PU29 GN-18-PTFE GROUND 1 1 C250-PV19 BK-14-TXL
1
J849-PV8 WH-18-PTFE 2 K990-PY2 GN-18-PTFE 2
GROUND 2 2 C250-PU20 BK-14-TXL GROUND 2 2 C250-PV20 BK-14-TXL K837-PV32 BR-18-PTFE 3 128-PY3 PK-18-PTFE 3
GROUND 3 C250-PU21 BK-14-TXL J849-PU8 WH-18-PTFE GROUND 3 3 C250-PV21 BK-14-TXL
3
K830-PV12 PU-18-PTFE 4 C254-PY4 BK-18-PTFE 4
GROUND 4 C250-PU22 BK-14-TXL K837-PU32 BR-18-PTFE GROUND 4 4 C250-PV22 BK-14-TXL
4
K830-PU12 PU-18-PTFE N895-PV4 PK-18-PTFE
GROUND 5 5 C250-PU23 BK-14-TXL PU-C53 GROUND 5 5 C250-PV23 BK-14-TXL K840-PV10 GY-18-PTFE
POWER IN 1 6 128-PU24 PK-14-TXL N895-PU4 PK-18-PTFE 1698670 POWER IN 1 6 128-PV24 PK-14-TXL K900-PV16 YL-18-PTFE
POWER IN
POWER IN
2
3
7
8
128-PU25 PK-14-TXL
128-PU26 PK-14-TXL
K840-PU10 GY-18-PTFE
K900-PU16 YL-18-PTFE
K900-PU53 YL-18-PTFE
K990-PU55 GN-18-PTFE
A
B
TERM RESISTOR PW
134-2540
POWER IN
POWER IN
2
3
7
8
128-PV25 PK-14-TXL
128-PV26 PK-14-TXL
K900-PV30 YL-18-PTFE K900-PV53 YL-18-PTFE
K900-PV54 YL-18-PTFE
FOR D6T ONLY
POWER IN 4 9 128-PU27 PK-14-TXL K900-PU30 YL-18-PTFE K900-PU53 YL-18-PTFE C POWER IN 4 9 128-PV27 PK-14-TXL
K900-PU54 YL-18-PTFE 10
K990-PV14 GN-18-PTFE
10
K990-PV31 GN-18-PTFE K990-PV55 GN-18-PTFE
CAT CAN A + 11 F711-PU28 YL-18-PTFE K990-PU14 GN-18-PTFE CAT CAN A + 11 F711-PV28 YL-18-PTFE K990-PV56 GN-18-PTFE
CAT CAN A - 12 F712-PU29 GN-18-PTFE K990-PU31 GN-18-PTFE K990-PU55 GN-18-PTFE CAT CAN A - 12 F712-PV29 GN-18-PTFE
K990-PU56 GN-18-PTFE 13
13
L929-PV3 BR-18-PTFE
CAT CAN C + 14 K900-PU30 YL-18-PTFE CAT CAN C + 14 K900-PV30 YL-18-PTFE L930-PV1 YL-16-PTFE PV-C53
CAT CAN C - K990-PU31 GN-18-PTFE L929-PU3 BR-18-PTFE PU-C917 CAT CAN C - 15 K990-PV31 GN-18-PTFE 1698670
15
L958-PV17 BU-18-PTFE
L930-PU1 YL-16-PTFE 1779649 16
K900-PV53 YL-18-PTFE A
16
N828-PV57 YL-18-GXL TERM RESISTOR PT 2
L958-PU17 BU-18-PTFE 17
K990-PV55 GN-18-PTFE B
17
101-PU40 RD-12-GXL 1 BATTERY (+) 134-2540
UENR4683-03 VOL 2 of 2

N828-PU57 YL-18-GXL 18
C
18
101-PU41 RD-12-GXL 2 BATTERY (+) N894-PV2 YL-16-PTFE
19
19
A283-PU48 BK-12-GXL 3 BATTERY (-)
N894-PU2 YL-16-PTFE 20
20
A283-PU49 BK-12-GXL 4 BATTERY (-) T801-PV34 GY-18-PTFE
21 21
22
22
23 T801-PU34 GY-18-PTFE 23
24 24
25
PV-C917
25
26 26
27
1779649
27
28
29
28
29 101-PV40 RD-12-GXL 1 BATTERY (+)
30 K837-PU32 BR-18-PTFE 30 K837-PV32 BR-18-PTFE 101-PV41 RD-12-GXL 2 BATTERY (+)
24 Page, (Dimensions: 34 inches x 28 inches)

A283-PV48 BK-12-GXL BATTERY (-)

C 31
32
31
32
33
A283-PV49 BK-12-GXL
3
4 BATTERY (-)
C
33
34 34
35 35
36 36
37 37
38 38
39 39
40 40

41 C249-PU33 BK-18-PTFE 41 C249-PV33 BK-18-PTFE

42 42
43 43
44 44
45 45
46 46
47 47
48 48
49 49
50 50
51 51

DCU KEY SWITCH 52 T801-PU34 GY-18-PTFE DCU KEY SWITCH 52

53
T801-PV34 GY-18-PTFE
53

BEAD FERRITE PT 2
444-4861
BEAD FERRITE PU 128-PV38 PK-16-GXL
444-4861 C250-PV51 BK-16-GXL
128-PU38 PK-16-GXL E740-PV52 GN-18-GXL
C250-PU51 BK-16-GXL F711-PV28 YL-18-PTFE
E740-PU52 GN-18-GXL F712-PV29 GN-18-PTFE
F711-PU28 YL-18-PTFE K840-PV10 GY-18-PTFE
F712-PU29 GN-18-PTFE K900-PV54 YL-18-PTFE
K840-PU10 GY-18-PTFE K990-PV56 GN-18-PTFE
K900-PU54 YL-18-PTFE N828-PV57 YL-18-GXL
K990-PU56 GN-18-PTFE N895-PV4 PK-18-PTFE
N828-PU57 YL-18-GXL T801-PV34 GY-18-PTFE
N895-PU4 PK-18-PTFE
T801-PU34 GY-18-PTFE

B B
PV-C918
PU-C918
2606728
2606728
1 K840-PV10 GY-18-PTFE
1 K840-PU10 GY-18-PTFE
2 N895-PV4 PK-18-PTFE
2 N895-PU4 PK-18-PTFE
3 K900-PV54 YL-18-PTFE
3 K900-PU54 YL-18-PTFE
4 K990-PV56 GN-18-PTFE
4 K990-PU56 GN-18-PTFE
5 T801-PV34 GY-18-PTFE
5 T801-PU34 GY-18-PTFE
6
6
7 F711-PV28 YL-18-PTFE
7 F711-PU28 YL-18-PTFE
8 F712-PV29 GN-18-PTFE
8 F712-PU29 GN-18-PTFE
9 128-PV38 PK-16-GXL
9 128-PU38 PK-16-GXL
10 C250-PV51 BK-16-GXL
10 C250-PU51 BK-16-GXL
11 E740-PV52 GN-18-GXL
11 E740-PU52 GN-18-GXL
12 N828-PV57 YL-18-GXL
12 N828-PU57 YL-18-GXL

SYMBOL DESCRIPTION ABBREV COLOR

(+) BATTERY
CIRCUIT CONNECTED RD RED
(+) BATTERY SWITCHED
WH WHITE
CIRCUIT NOT CONNECTED
(-) BATTERY / SENSOR RETURN
OR ORANGE
ELECTRICAL CONNECTION TO
SENSOR / ACTUATOR SUPPLY MACHINE STRUCTURE
YL YELLOW
INTERNAL ELECTRICAL CONNECTION
CONTROL (POSITIVE) FROM ECM TO SURFACE OF COMPONENT PK PINK

CONTROL (RETURN) FROM ECM CONNECTOR BK BLACK

CAN C DATA LINK H# GY GRAY

CIRCUIT GROUPING DESIGNATION
PU PURPLE
J1939 DATA LINK ATCH WIRE, CABLE, COMPONENT
BR BROWN
A HIGHWAYS
SPLICE
GN GREEN
A
BLADE, SPADE, RING OR SCREW
TERMINAL BU BLUE

THIS SCHEMATIC IS FOR THE C9.3 INDUSTRIAL ENGINE ELECTRICAL SYSTEM

VOLUME 2 of 2: DEF TANK WIRING
MEDIA NUMBER: UENR4683-03
SCHEMATIC PART NUMBER: 491-3646, CHANGE: 00, VERSION: -
Components are shown installed on a fully operable engine in a non powered state.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

7 6 5 4 3 2 1