Mạch điện hệ thống điều khiển phun dầu động cơ D6CC 2020 trên

các dòng Hyundai tải

EC
U
PR
O
C
EN
TE
R
26/6/2021 Global Service Way - Technical Information

2019 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (1) SD313-1

ETC Terminal Information

1 5 9 13 17 21 25 29 33 37 41 45 49 53 57 60
1 5 9 13 17 21 25 29 33 37 41 45 49 53 57 60 1 5 9 13 17 21 25 29 33 37 41 45 49 53 57 60
2 6 10 14 18 22 26 30 34 38 42 46 50 54 2 6 10 14 18 22 26 30 34 38 42 46 50 54 2 6 10 14 18 22 26 30 34 38 42 46 50 54
57 61 58 61 58 61
3 7 11 15 19 23 27 31 35 39 43 47 51 55 3 7 11 15 19 23 27 31 35 39 43 47 51 55 3 7 11 15 19 23 27 31 35 39 43 47 51 55
4 8 12 16 20 24 28 32 36 40 44 48 52 56 58 62 4 8 12 16 20 24 28 32 36 40 44 48 52 56 59 62 4 8 12 16 20 24 28 32 36 40 44 48 52 56 59 62

C101-1 E100-1 E100-2

PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION
1 G Engine Speed 32 Gr Stop Signal Relay Control 1 B Injector #1 (NCV LO) 34 R/B Boost Inlet Air Temp. 1 - - 33 L Delta Pressure (Signal)
2 B ENG ECU Relay Control 33 W Pedal Sensor (Demend) 2 G Injector #1 (NCV HI) 35 G Jake SOL #2 (GND) 2 - - 34 Br Delta Pressure (0V)
3 - - 34 R Pedal Sensor (Power) 3 L Injector #1 (SCV HI) 36 B [Exhaust Brake] 3 - - 35 - -
4 W Engine Brake #1 35 G CAN1 (Low) 4 G/B Injector #1 (SCV LO) Exhaust Brake 4 - - 36 - -
5 - - 36 L/R Clutch Switch 5 L Injector #2 (NCV LO) B [Jake Brake] 5 Br/O Remote Pedal Sensor (SIG) 37 - -
6 - - 37 B Pedal Sensor (Ground) 6 P Injector #3 (NCV HI) Jake SOL #2 (LO/HI) 6 Br/W Remote Pedal Sensor (PWR) 38 - -
7 Br Start Relay Control (Start Inhibit) 38 - - 7 O Injector #3 (SCV HI) 37 - - 7 B/W Remote Pedal Sensor (GND) 39 Y Air Heater Monitor
8 W/B Engine Brake #2 39 L [W/O Mixer High] 8 G Injector #2 (SCV LO) 38 - - 8 - - 40 - -
9 B/O Start Relay Control (Sub Start) PTO Safety Switch 9 O Injector #3 (NCV LO) 39 - - 9 G/B Air Mass Flow (14V) 41 Y/R Coolant Temp. (Signal)
10 - - 40 L/B Pedal Switch (N/O) 10 B Injector #5 (NCV HI) 40 G Engine Brake Lamp 10 G/O Air Mass Flow (0V) 42 G/R Coolant Temp. (0V)
11 Br Cruise/Engine PTO Switch (Enable) 41 Gr Pedal Switch (N/C) 11 Y Injector #5 (SCV HI) 41 Y Fuel Temp. 11 - - 43 G EGR Temp. (0V)
12 W P/S Oil Temp. Switch 42 Y CAN1 (High) 12 P Injector #3 (SCV LO) 42 R/B 5V Fuel Pressure 12 - - 44 - -
EC

13 - - 43 P Neutral Switch 13 W Injector #4 (NCV LO) 43 G Jake SOL #3 (GND) 13 G/O Air Mass Flow (Signal) 45 Y [W/O Mixer High]
14 - - 44 Br ON Input 14 G/B Injector #2 (NCV HI) 44 B Jake SOL #3 (MED/HI 2) 14 - - Remote PTO INC Switch
15 - - 45 Y/W CAN2 (High) 15 B Injector #2 (SCV HI) 45 Y Fuel Pressure 15 - - 46 - -
16 G/O Cruise/Engine PTO Switch (RES/DEC) 46 Y CAN1 (High) 16 R Injector #4 (SCV LO) 46 G/W 0V Fuel Pressure 16 - - 47 - -
17 - - 47 Br Diagnostic Switch 17 Y Injector #5 (NCV LO) 47 - - 17 - - 48 - -
U

18 G/W Check Engine 48 W Vehicle Speed 18 R Injector #4 (NCV HI) 48 Y/O Not Used 18 - - 49 R/O [W/O Mixer High]
19 - - 49 - - 19 W Injector #4 (SCV HI) 49 G CKPS (+) 19 G/W Not Used Remote PTO DEC Switch
20 L Cruise/Engine PTO Switch (SET/INC) 50 G CAN1 (Low) 20 B Injector #5 (SCV LO) 50 O CKPS (-) 20 - - 50 - -
PR

21 G Parking Switch 51 - - 21 L Injector #6 (NCV LO) 51 - - 21 - - 51 - -

22 G/B High Coolant Temp. Lamp 52 - - 22 G/B Injector #6 (NCV HI) 52 B Air Heater Lamp 22 - - 52 - -
23 - - 53 G/W CAN2 (Low) 23 R Injector #6 (SCV HI) 53 R CMPS (+) 23 - - 53 - -
24 Br/O A/C Thermo High 54 G CAN1 (Low) 24 W Injector #6 (SCV LO) 54 L CMPS (-) 24 - - 54 - -
25 - - 55 - - 25 B Jake SOL #1 (MED/HI 1) 55 - - 25 L/B AMS Air Temp. (Ambient) 55 - -
O

26 - - 56 - - 26 G Jake SOL #1 (GND) 56 G CRS/PTO/RSG Lamp 26 Lg AMS Air Temp. (0V) 56 - -

27 Y CAN1 (High) 57 B Ground (GC11) 27 B 0V Boost 57 - - 27 O Check Engine 57 - -
28 - - 58 B Ground (GC11) 28 R 5V_I_Boost 58 - - 28 - - 58 - -
29 Remote PTO Enable Switch 59 B Ground (GC11) 29 - - 59 - - 29 R EGR Temp. (Signal) 59 - -
C

R [W/O Mixer High] 60 R ENG ECU Relay ON Input 30 Br Boost Pressure 60 - - 30 L Delta Pressure (5V) 60 - -
R/Y [With Mixer High] 61 P ENG ECU Relay ON Input 31 - - 61 - - 31 - - 61 - -
30 - - 62 Y ENG ECU Relay ON Input 32 - - 62 - - 32 Y Air Heater Relay Control 62 - -
EN

31 - - 33 - -
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
26/6/2021 Global Service Way - Technical Information

2019 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (2) SD313-2

HOT IN ON HOT AT ALL TIMES
SMART
JUNCTION
BLOCK
ENG ENG
ECU ECU
5A 20A

ENG
ECU
RELAY AIR
HTR
5A

ENG
ECU
5A

B L(ZF A/T) O
L(M/T-DYMOS) INSTRUMENT See
W/B(M/T-FSO) CLUSTER R/W R R Illuminations Gr O Y
Gr(M/T-ZF) 15
M01-A G/O
C30-A(ZF A/T) CRANK- ENGINE
C30-D(M/T-DYMOS) SHAFT COOLANT
C30-F(M/T-FSO) (9) (C116-1) INSTRUMENT POSITION TEMPERATURE
2 E13(M/T-ZF) 1 C104 [1] [C116-2] 3 M27 5 10 M14 1 5 M61 M01-B CLUSTER SENSOR SENSOR
NEUTRAL POWER SPECIAL CLUTCH STEERING AUTO AIR 11
SWITCH STEERING CONNEC- SWITCH WHEEL CRUISE HTR
OIL ( ) : W/O Mixer High REMOTE RELAY
[ ] : With Mixer High
TOR IND. ILL. SWITCH
TEMPERATURE CONTROL
SWITCH SWITCH 29 30 11 33 31 34
1 C30-A(ZF A/T) 2 3 M61
2 C104 (RIGHT) M01-B 2 1 E109 1 3 E102
C30-D(M/T-DYMOS) 4 M27 7 4 1 8 M14
(8) (7) (3) (2) (5) (1) (10) (C116-1) (4) (C116-1)
C30-F(M/T-FSO) O(EURO 2/3)
[2] [C116-2]
E13(M/T-ZF) Br/O B/O B L/W(EURO 4)
CLOCK EURO 4 EURO 2/3
SPRING CAMSHAFT
G G C110(EURO 2/3) POSITION
See Easy Hill Start See 1 E103(EURO 4) SENSOR
(EHS) System See P.T.O 4 3 M23 Illuminations
AIR G/W G/W
Control HEATER
System GM01 RELAY &
MONITORING
See Assist See Vehicle See Starting See See Data
Brake System Speed System System Parking See Stop See A/C Link Details 2 E103(EURO 4) 2 1 E108
L/R L/R EURO 2/3 EURO 4
Brakes Lamps Control System

(R)
EC

Br B R P Y W W/B W G P W B/O Br G G L Y R/O Br/O Br/W B/W [R/Y] With W/O Gr L G/W Br/O Br Y G Y G Y/W G/W Y Y G/B O B B G G R L O G G/R Y/R
PTO PTO
C101-1 E100-2 C101-1 E100-2 C101-1 E100-2 C101-1 E100-1 E100-2
44 2 60 61 62 4 8 48 1 43 12 9 7 21 1 39 45 49 5 6 7 29 36 32 20 16 24 11 42 50 54 46 27 35 45 53 39 32 22 27 18 52 52 40 56 53 54 50 49 42 41

ETC
U

6 7 5 30 34 33 29 43 10 9 13 25 26 34 27 30 28 45 46 41 42 47 34 33 37 41 40 59 58 57 36 26 25 35 36 43 44 3 4 2 1 15 8 14 5 7 12 6 9 19 16 18 13 11 20 10 17 23 24 22 21
E100-2 E100-1 C101-1 E100-1

Br/W B/W Br/O L Br L R G G/O G/B G/O L/B Lg R/B B Br R Y G/W Y R/B Br R W B Gr L/B B B B B G B G B G B L G/B G B B G G/B L O P P O W R R W Y B B Y R W G/B L
PR

W R

2 1 E111 2 M16-E 2 C105 1 E123-1 1 2 3 4 E121-2 1 2 3 4 E121-4 1 2 3 4 E121-6

ETC EXHAUST JAKE
CHECK MAGNETIC BRAKE
SWITCH VALVE SOLENOID
#2 SCV NCV SCV NCV SCV NCV
EGR
TEMPERA- 1 M16-E 1 C105 1 E123-2 INJECTOR INJECTOR INJECTOR
O

TURE #2 #4 #6
SENSOR
EURO 4 B B B
3 4 1 2 E104 2 1 3 4 E105
2 3 1 5 4 E119 M01-B
2 3 1 C103 1 3 2 E07 3 1 2 5 4 6 M18
35
1 E122-1 1 E124-1 1 2 3 4 E121-1 1 2 3 4 E121-3 1 2 3 4 E121-5
JAKE JAKE
C

BRAKE BRAKE
INSTRU- SOLENOID SOLENOID
AMS ATS MENT #1 #3 SCV NCV SCV NCV SCV NCV
CLUSTER
ENGINE RPM PRESSURE MASS AIR FLOW BOOST FUEL TEMPERATURE ACCEL PEDAL 1 E122-2 1 E124-2 INJECTOR INJECTOR INJECTOR
CONTROL SENSOR SENSOR PRESSURE & PRESSURE SENSOR POSITION SENSOR #1 #3 #5
With Mixer High EURO 4 EURO 4 SENSOR
EURO 4
EN

EURO 4 GM01 GC11

TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
26/6/2021 Global Service Way - Technical Information

2019 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (3) SD313-3

HOT IN ON HOT AT ALL TIMES
SMART
See Power Distribution See Power Distribution JUNCTION
(SD110-5) (SD110-4) BLOCK
ENG ENG P.31/43
ECU ECU C.90-5/7/8/9
5A 20A AIR ENG
HTR ECU
See Passenger 5A 5A
Compartment Fuse Details
(SD120-14)
ENG
ECU See Passenger To EDU
RELAY Compartment Fuse Details A Relay
(SD120-14) (SD313-5)

48 28 31 32 33 I/P-J 38 I/P-F 47 I/P-K 47 I/P-L 9 6 I/P-J

M/T ZF A/T
0.85O 0.85Gr
0.85R/W
SUB ZF DYMOS/FSO
5 1 M61 RELAY
0.85Br 0.85B 0.85R 0.85P 0.85Y BLOCK C
AIR
HTR 0.5B 0.5B 0.5B 0.85L(ZF A/T) 0.85O
RELAY 0.5Gr(ZF) To Special
P.30 11 EC04 0.85L(DYMOS) Connector
C.10-21 0.5W/B(FSO) (SD313-7)
P.121
3 2 M61 0.5B
C30-D (DYMOS)
2 E13 2 C30-F (FSO) 2 C30-A 1 C104
EC

0.85L 0.85O NEUTRAL NEUTRAL NEUTRAL POWER

SWITCH SWITCH SWITCH STEERING OIL
20 19 MC91 P.42 P.119/ P.137/ P.204 TEMPERATURE
202 139/206 C.30-6 SWITCH
EURO 4 EURO 2/3 C.24-1 C.30-7
1 E13 1 C30-D (DYMOS) 1 C30-A 2 C104
C30-F (FSO) C.32-5
U

0.85L 0.85O 0.85O 0.5W/B

19 34 EC101 10 EC04 P.121

PR

P.66
0.5Y 0.75L/W 0.5Gr 0.85L(DYMOS 0.85L 0.85P 0.85W
0.5W/B(FSO)

ZF DYMOS/FSO
B
M/T ZF A/T
O

To Air Heater
Relay & Monitoring See Easy Hill Start
(SD313-4) (EHS) System
44 2 60 61 62 C101-1 32 E100-2 (SD956-2) 43 12 C101-1
ETC
C

ON ENG ECU Air Heater Neutral P/S Oil

Input Relay Relay Switch Temp. CONTROL
ENG ECU Relay MODULE
Control ON Input Control Switch
P.187
EN

C.20-2/32-1
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
26/6/2021 Global Service Way - Technical Information

2019 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (4) SD313-4

Not Used

+ BATTERY AIR 35 EC101

HEATER
RELAY & P.66
12V MONITORING 0.5R/B
- FUSE 2 E102
ENGINE EGR PRESSURE
SENDER COOLANT TEMPERATURE SENSOR
60R 60R TEMPERATURE SENSOR EURO 4
SENSOR SENSOR EURO 4
P.58 P.79
N/A C.23-2
BATTERY C.20-5
+
2 1 E111 3 2 1 E07
2 1 E103 1 C110 P.186
12V P.59 P.65 1 3 E102 C.20-6 0.5G/B 0.5G 0.5G/O
C.20-5 C.32-6
-
0.5Y 0.75L/W 0.85O 3 2 1 EC12
P.82
EURO 4 EURO 2/3 0.5G/R 0.5Y/R 0.5R 0.5G 0.5G/B 0.5G 0.5G/O
60B AIR
HEATER 11 20 21 EC101
B P.66
From AIR HTR Relay 0.5Br 0.5L 0.5L
BODY START (SD313-3)
GROUND MOTOR 39 42 41 29 43 34 33 30 E100-2

Air Heater 0V Signal Signal 0V 0V Signal 5V ETC

CONTROL
EC

Monitor
Coolant Temp. EGR Temp. Delta Pressure MODULE
P.187
C.20-1/2
Boost CMPS CKPS AMS Air Temp. Air Mass Flow
Inlet Air 0V Boost 5V_I_ 5V Fuel Fuel 0V Fuel Fuel
Temp. Boost Pressure Boost Pressure Temp. Pressure Pressure (+) (-) (+) (-) Ambient 0V Signal 14V 0V
U

34 27 30 28 42 41 46 45 53 54 49 50 E100-1 25 26 13 9 10 E100-2

0.5R/B 0.5B 0.5Br 0.5R 0.5R/B 0.5Y 0.5G/W 0.5Y 0.5R 0.5L 0.5G 0.5O 0.5L/B 0.5Lg 0.5G/O 0.5G/B 0.5G/O
PR
O

3 4 1 2 E104 4 3 1 2 E105 2 1 E108 1 2 E109 5 4 1 3 2 E119

BOOST FUEL CAMSHAFT CRANK- MASS AIR
PRESSURE TEMPERA- POSITION SHAFT FLOW
SENSOR TURE & SENSOR POSITION ATS AMS SENSOR
C

EURO 4 PRESSURE P.63 SENSOR EURO 4

SENSOR C.20-6 P.63
P.59/188 EURO 4 C.20-6 P.67
C.20-5 C.20-7
EN

P.61/62
C.20-5
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
26/6/2021 Global Service Way - Technical Information

2019 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (5) SD313-5

HOT AT ALL TIMES
SMART
See Power Distribution JUNCTION
(SD110-4) BLOCK
P.31
EDU C.90-2/3
15A From ENG To Clock
ECU 5A A D Spring
(SD313-3) (SD313-6)

39 I/P-C 25 I/P-D

1.25R 0.85W
SUB
1 4 M66-1 RELAY
EDU BLOCK
RELAY
P.30
C.10-22

5 2 M66-1
See Data Link Details
1.25R 0.85B (SD200-4)
(SD200-5)
23 MC91
P.42
1.25R

1 EC101
P.66 GM04 P.22 0.5B 0.5Y 0.85Y/W 0.85G/W 0.85Y 0.85Y 0.85G 0.85G
0.75Br
EC

13 15 16 E101 45 53 27 42 46 54 50 35 C101-1

EDU Relay High Low EDU High Low ETC

ON Input CONTROL CONTROL
MODULE CAN1_High CAN1_Low MODULE
CAN2 CAN2
P.60/187 Start Relay Control P.187
Position Sensor Motor C.20-5 Engine Torque C.20-1/
Shield 20-2/32-1
U

Service Selection Sub Start Vehicle Engine Parking

Ground U V W PWR GND W V U Ground Mode Lamp Start Inhibitot Speed Speed Switch
5 1 2 3 8 4 12 11 10 14 E101 19 E100-2 48 E100-1 9 7 48 1 21 C101-1
PR

N/A 0.5R/B 0.5W 0.5Br 0.5R 0.5B 0.5B 0.5G 0.5Br 0.75Br/B 0.5G/W 0.5Y/O 0.85B/O 0.85Br 0.85W 0.85G 0.85G

15 9 6 EC101
P.66
1.25B
O

See Ground
0.5R/B 0.5W 0.5Br Distribution
(SD130-14) See Parking
Not Used See Starting See Vehicle Brakes
4 3 2 1 5 6 7 8 E107 1.25B System Speed System (SD597-1)
EGR (SD360-1) (SD436-1)
C

U V W PWR GND W V U ACTUATOR

Position Sensor Motor P.68
C.20-6
EN

GC11
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
26/6/2021 Global Service Way - Technical Information

2019 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (6) SD313-6

SMART
JUNCTION
From ENG To Instrument BLOCK
ECU 5A D E Cluster
(SD313-5) (SD313-9) P.31
C.90-3

13 26 I/P-D
See Illuminations
(SD941-5)

0.5G/O 0.5B 0.5Br 0.5R See Illuminations 0.85R

(SD941-2)
5 6 12 M23
CLOCK
SPRING
P.10 0.5G/O
C.10-12
5 10 M14 3 M27
STEERING AUTO CLUTCH
1 7 8 WHEEL CRUISE SWITCH
STEERING SWITCH P.5
(+) (-) COM IND. ILL. P.19
WHEEL C.10-13
REMOTE C.10-9
SET RES CONTROL
SWITCH 4 M27
(RIGHT) 7 4 1 8 M14
ILL.
See P.T.O
0.5Br/O 0.5B/O 0.5B Control System
4 3 (SD471-1)
EC

See Illuminations
(SD941-2)
CLOCK 0.85L/R 0.85L/R
SPRING
P.10 See Ground
C.10-12 Distribution UMB W/O With
U

(SD130-2) PTO PTO

4 3 M23
See Assist See A/C
Brake System Control System
PR

0.5L 0.5G/W 0.5Br 2.0B

(SD598-1) See Stop (SD971-3)
(SD598-7) Lamps (SD971-5)
(SD927-1) (SD971-7)
10 11 9 MC91 1 MC81
P.42 P.42

0.5L 0.5G/O 0.5Br 0.5W 0.5W/B 0.5L/R 0.85Gr 0.5Br/O

O

GM01 P.22
20 16 11 4 8 36 32 24 C101-1
SET/INC RES/DEC Enable Engine Engine Clutch Stop Signal A/C Thermo ETC
CONTROL
C

Brake #1 Brake #2 Switch Relay High

Control MODULE
Cruise/Engine PTO Switch
P.187
C.32-1
EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
26/6/2021 Global Service Way - Technical Information

2019 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (7) SD313-7

W/O MIXER HIGH With MIXER HIGH

SPECIAL
S P E C I A L C O N N E C T O R CONNECTOR
ENGINE
8 7 4 9 3 2 5 1 10 C116-1 1 2 C116-2 RPM
CONTROL
C.32-7 C.32-7 C.32-5
0.85G 0.85L 0.85R 0.85R/W 0.85O 0.85Gr 0.85B 0.85R 0.85W 0.85R/W 0.85R/Y
1 3 2 C103
0.85G 0.85G C C
18 MC81 FromENG FromENG 0.85B 0.85R 0.85W
ECU 5A ECU 5A
P.42 (SD313-3) (SD313-3)
0.5G

F 18 17 14 13 12 EC101 14 12 13 EC101
P.66 P.66
To Instrument 0.5Y 0.5R/O 0.5Br/O 0.5Br/W 0.5B/W 0.5Br/O 0.5B/W 0.5Br/W
Cluster
(SD313-9)
1 39 29 C101-1 45 49 5 6 7 E100-2 29 C101-1 5 7 6 E100-2

Engine PTO Enable INC DEC Signal Power Ground Remote PTO Signal Ground Power ETC
Speed Safety Switch Switch Switch Enable CONTROL
Switch Remote Pedal Sensor Switch Remote Pedal Sensor MODULE
Remote PTO P.187
C.20-1/
Pedal Sensor Pedal Switch 20-2/32-1
Ground Exhaust Diagnostic
Power Demend Ground N/C N/O Brake Switch

34 33 37 41 40 57 58 59 C101-1 36 E100-1 47 C101-1

0.85B 0.5Br
EC

3 EC101 5 MC81
0.85R 0.85W 0.85B 0.85Gr 0.85L/B P.66 P.42
0.85R

7 6 8 17 16 21 MC81
U

0.5Br
P.42 0.85R 0.85R
2 C105 2 MC91 2 M16-E
PR

EXHAUST P.42 ETC CHECK

MAGNETIC 0.5W SWITCH
0.85R 0.85W 0.85B 0.85Gr 0.85L/B 0.85B 0.85B 0.85B 0.85B 0.85B VALVE P.6
P.134/175/177 C.10-10
C.32-5 G
1 C105 1 M16-E
To Instrument 0.5B
O

3 1 2 5 4 6 M18 UCG Cluster

0.85B
See Ground (SD313-9)
ACCEL See Ground
PEDAL Distribution
(SD130-14) Distribution UMA
POSITION 2.0B 1.25B (SD130-2)
SENSOR
C

P.11 2.0B
C.10-11
EN

GC11 GM01 P.22

TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
26/6/2021 Global Service Way - Technical Information

2019 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (8) SD313-8

1 3 E121-1 1 3 E121-3 1 3 E121-5

INJECTOR INJECTOR INJECTOR
SCV NCV #1 SCV NCV #3 SCV NCV #5
P.64/190 P.64/190 P.64/190
C.20-8 C.20-8 C.20-8

2 4 E121-1 2 4 E121-3 2 4 E121-5

0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W

2 3 4 1 6 7 12 9 10 11 20 17 EE01
P.64/190

0.85G 0.85L 0.85G/B 0.85B 0.85P 0.85O 0.85P 0.85O 0.85B 0.85Y 0.85B 0.85Y

2 3 4 1 6 7 12 9 10 11 20 17 E100-1

NCV SCV SCV NCV NCV SCV SCV NCV NCV SCV SCV NCV ETC
HI HI LO LO HI HI LO LO HI HI LO LO CONTROL
MODULE
Injector #1 Injector #3 Injector #5 P.187
C.20-1
Injector #2 Injector #4 Injector #6

NCV SCV SCV NCV NCV SCV SCV NCV NCV SCV SCV NCV
HI HI LO LO HI HI LO LO HI HI LO LO
EC

14 15 8 5 18 19 16 13 22 23 24 21 E100-1

0.85G/B 0.85B 0.85G 0.85L 0.85R 0.85W 0.85R 0.85W 0.85G/B 0.85R 0.85W 0.85L
U

14 15 8 5 18 19 16 13 22 23 24 21 EE01
P.64/190
PR

0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W

2 4 E121-2 2 4 E121-4 2 4 E121-6

INJECTOR INJECTOR INJECTOR
SCV NCV #2 SCV NCV #4 SCV NCV #6
O

P.64/190 P.64/190 P.64/190

C.20-8 C.20-8 C.20-8
C

1 3 E121-2 1 3 E121-4 1 3 E121-6

EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
26/6/2021 Global Service Way - Technical Information

2019 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (9) SD313-9

HOT AT ALL TIMES HOT IN ON OR START
See Power Distribution See Power Distribution SMART
(SD110-4) (SD110-3) JUNCTION
BLOCK
FUSE
SWITCH P.31
ROOM C.90-2/
CLUSTER
LAMP 3/5
10A
10A
To Water From ENG
H Level Sensor ECU 5A E See Passenger See Passenger
(SD313-10) (SD313-6) Compartment Fuse Details Compartment Fuse Details
(SD120-16) (SD120-3)

34 31 I/P-D 32 I/P-C 27 I/P-F

0.5R
0.5Y 0.5P 0.5Y/B
0.5R
11 M01-B 18 21 31 M01-A
Over INSTRUMENT
Heat CLUSTER
EXH JNKE PRE CHECK OVER ENG P.7
BRAKE BRAKE HEAT'G ENG OBD HEAT IMMO PTO/ C.10-1
IG2
CRUISE
MONO LCD MOLO
(CRUISE/PTO LCD
5V REG ENABLE)
General

MICOM
IG2 IG2 IG1
IG2 IG2 IG2
EC

I/F CAN1 TRANSCEIVER

Check Pre Jake Cruise/ Oil Exh. P_ S_

OBD ENG P_GND Heating P_GND Brake P_GND ENG PTO B/Pass P_GND Brake High Low GND GND

30 29 33 31 34 4 35 M01-B 15 34 35 22 28 M01-A
EURO 2/3 EURO 4
U

0.5Br 0.5G 0.5L/O 0.5G 0.5W 0.5G 0.5Y 0.5G 0.5B 0.5B
0.5G/W 0.5G/W 0.5Br
19 14 MC81 18 13 MC91
PR

EURO 4 EURO 2/3 P.42 P.42 0.5G 0.5L

17 16 MC91 See Data
0.5Br 0.5G 0.5P/O 0.5G Link Details
P.42
0.5Br (SD200-3)
G F
10 5 7 4 32(EURO 2/3) EC101 From Exhaust From Special
36(EURO 4) P.66 Magnetic Valve Connector 10 MR01
O

(SD313-7) (SD313-7) P.4

0.5G/W 0.5O 0.5B 0.5G 0.5G
Not Used 0.5L
18 C101-1 27 E100-2 52 40 56 E100-1
ETC 10 R16
C

Check Check Air Heater Engine CRS/PTO

Engine Engine Lamp Brake /RSG CONTROL DIGITAL
MODULE RPM
Lamp Lamp Signal TACHOGRAPH
P.187 In P.94/96
EN

C.20-1/20-2/32-1 C.60-3
GM02 P.22 GM10 P.30
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
26/6/2021 Global Service Way - Technical Information

2019 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (10) SD313-10

SMART
JUNCTION
From Instrument BLOCK
Cluster H
(SD313-9) P.43
C.90-7/8

2 I/P-J 4 I/P-K

0.5G/B 0.85Y/R

1 E122-2 1 E123-2 1 E124-2 2 C38

JAKE JAKE JAKE WATER
BRAKE BRAKE BRAKE LEVEL
SOLENOID SOLENOID SOLENOID SENSOR
#1 #2 #3 P.46
C.30-9
1 E122-1 1 E123-1 1 E124-1 1 C38
P.64/190 P.64/190 P.64/190
C.20-9 C.20-9 C.20-9
EC

0.85B
0.85W 0.85W 0.85W 0.85W 0.85W 0.85W
U

See Ground
26 25 27 28 29 30 EE01 Distribution UCC
PR

P.64/190 (SD130-10)

0.85G 0.85B 0.85G 0.85B 0.85G 0.85B

0.85B
O

26 25 35 36 43 44 E100-1 22 C101-1
GND MED/HI 1 GND LO/HI GND MED/HI 2 High Coolant ETC
Temp. Lamp CONTROL
Jake Solenoid MODULE
C

P.187
C.20-1/32-1
EN

GC01 P.155
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1