Electrical & Electronics - Troubleshooting

ECU (Electronic Control Unit)

1. ECU Connector 1 (Chassis) - 2. ECU Connector 2 (Engine)

4
5399 Rev. 1.2 Apr 2017
 Electrical & Electronics - Troubleshooting

ECU Connector 1 (Chassis)

Pin Component
Pin Component 25 Batt 3 (+)
1 Batt 4 (+) 26 Batt 5 (+)
2 Heated DEF hose outlet (-) 27 Fuel filter heater relay (+)
3 Batt 1 (-) 28 Batt 2 (-)
4 Heated DEF hose inlet/backflow (-) 29 Low side power stage 11 (-)
5 Batt 4 (-) 30 Free
6 Free 31 DEF level sensor
7 DEF pressure sensor signal 32 Catalyst upstream temperature sensor
8 DEF temperature sensor signal 33 Free
9 Catalyst downstream temperature sensor 34 Engine speed output
10 DEF temperature sensor (-) 35 Free
11 Free 36 Free
12 Free 37 Free
13 Water in fuel sensor signal 38 Free
14 Free 39 DEF pressure/level/temp (-)
15 Humidity sensor 40 Air temperature sensor signal
16 Exhaust gas temperature upstream sensor 41 Free
17 Free 42 Free
18 Free 43 WIF/humidity & temp sensor (-)
19 Starter relay (+) 44 OBD led
20 ATS sensors relay (+) 45 ATS sensors Relay (-)
21 Free 46 CAN high
22 After Run Disconnect Relay (+) 47 CAN low
23 Dosing Module (+) 48 Free
24 After Run Disconnection Relay (+)

5
5399 Rev. 1.2 Apr 2017
 Electrical & Electronics - Troubleshooting

Pin Component Pin Component

49 Batt 2 (+) 73 Batt 1 (+)
50 DEF pump / revert / heat valve (+) 74 Intake air heater
51 Diagnostic LED (-) 75 Batt 3 (-)
52 Batt 5 (-) 76 Low side power stage 14 (-)
53 Free 77 Diagnostic LED (+)
54 Free 78 Free
55 Free 79 Free
56 Free 80 Free
57 Free 81 Free
58 Free 82 Free
59 Free 83 Intake air heater (-)
60 Free 84 DEF pump signal
61 Fuel Filter Heater relay (-) 85 DEF reverting valve (-)
62 Free 86 Free
63 Key switch start signal 87 Free
64 Free 88 Starter relay (-)
65 Free 89 DEF pump (-)
66 Free 90 Humidity sensor (+)
67 Free 91 Free
68 DEF pressure sensor (+) 92 Free
69 Key on signal 93 DEF Heated line relay (-)
70 ECU ISO K-line interface 94 Free
71 CAN (high) 2 95 CAN (low) 2
72 DEF Tank Heating Valve (-) 96 DEF Dosing Module (-)

6
5399 Rev. 1.2 Apr 2017
 Electrical & Electronics - Troubleshooting

ECU Connector 2 (Engine)

Pin Component Pin Component

1 Injector 1 “low”, Bank 2, Cylinder 5 25 Injector 1 “high”, Bank 2, Cylinder 5
2 Injector 2 “low”, Bank 2, Cylinder 6 26 Injector 2 “high”, Bank 2, Cylinder 6
27 Injector 3 “high”, Bank 2, Cylinder 4
3 Injector 3 “low”, Bank 2, Cylinder 4
28 Free
4 Free
29 Free
5 Free
30 Free
Engine oil pressure and temperature
6 Engine oil pressure and temperature sensor:
sensor: ground for frequency input 3 31
supply +5V
Boost pressure and air temperature sensor:
7 32 Free
supply +5V
8 Free 33 Free
9 Free 34 Free
Engine oil pressure and temperature sensor:
10 Free 35
pressure signal
11 Rail pressure sensor: supply +5V
36 Rail pressure sensor: pressure signal
Fuel temperature sensor: NTC temperature
12 Boost pressure and air temperature sensor: NTC
signal 37
temperature signal
Engine oil pressure and temperature
13 38 Free
sensor: NTC temperature signal
14 Free Coolant temperature sensor: NTC temperature
39
signal
15 Free
40 Free
16 Free
41 Free
Exhaust flap: Controller Area Network 2
17 42 Free
high (CAN H)
Exhaust flap: Controller Area Network 2 low 43 Free
18
(CAN L) 44 Free
19 Free 45 Free
20 Free 46 Free
21 Free 47 Free
22 Free 48 Free
23 Free
24 Free

7
5399 Rev. 1.2 Apr 2017
 Electrical & Electronics - Troubleshooting

Pin Component Pin Component

49 Injector 1 “high”, Bank 1, Cylinder 1 73 Injector 1 “low”, Bank 1, Cylinder 1

50 Injector 2 “high”, Bank 1, Cylinder 3 74 Injector 2 “low”, Bank 1, Cylinder 3

51 Injector 3 “high”, Bank 1, Cylinder 2 75 Injector 3 “low”, Bank 1, Cylinder 2
52 Free 76 Free
53 Free 77 Free
54 Free 78 Free
55 Free 79 Free
56 Free
80 Free
57 Free
81 Free
58 Fuel high pressure pump metering unit: supply
82 Free
Fuel/coolant temperature sensor: common
59
ground analog input 18 83 Fuel high pressure pump metering unit:
60 Rail pressure sensor: ground 84 Free
61 Free
85 Free
62 Free Boost pressure and air temperature sensor:
86
63 Free pressure signal
64 Free 87 Free
Crankshaft rpm increment speed sensor: signal 88 Free
65
negative
Crankshaft rpm increment speed sensor: signal 89 Free
66
positive Boost pressure and air temperature sensor:
90
Camshaft timing segment speed sensor: signal ground analog input 5
67
negative 91 Free
Camshaft timing segment speed sensor: signal
68 92 Free
positive
69 Free 93 Free
70 Free 94 Free
71 Free 95 Free
72 Free 96 Free

8
5399 Rev. 1.2 Apr 2017