Caddy Tig 1500i
Caddy Tig 1500i
Caddy Tig 1500i
Caddy®
Tig 1500i
Tig 2200i
Instruction manual
0460 443 201 GB 20130412 Valid for serial no. 803-xxx-xxxx to 927-xxx-xxxx
Downloaded from www.Manualslib.com manuals search engine
-2-
TOCe -4-
1 SAFETY
Users of ESAB equipment have the ultimate responsibility for ensuring that anyone who works on or
near the equipment observes all the relevant safety precautions. Safety precautions must meet the
-5-
bt34d1ea © ESAB AB 2013
WARNING
Arc welding and cutting can be injurious to yourself and others. Take precautions when welding and
cutting. Ask for your employer's safety practices which should be based on manufacturers' hazard
data.
ESAB can provide you with all necessary welding protection and accessories.
WARNING
Do not use the power source for thawing frozen pipes.
CAUTION
Read and understand the instruction manual before
installing or operating.
CAUTION
This product is solely intended for arc welding.
CAUTION
Class A equipment is not intended for use in residential locations where
the electrical power is provided by the public low-voltage supply system.
There may be potential difficulties in ensuring electromagnetic
compatibility of class A equipment in those locations, due to conducted
as well as radiated disturbances.
-6-
bt34d1ea © ESAB AB 2013
2 INTRODUCTION
The Tig 1500i / 2200i is a TIG welding power source, which can also be used for
MMA welding. It can be used direct current (DC).
2.1 Equipment
The power source is supplied with a 3 m welding cable complete with a TIG-torch,
3 m return cable, 3 m mains cable, instruction manual for power source and control
panel, see Ordering information on page 20.
Instruction manuals in other languages can be downloaded from the website,
www.esab.com.
See the separate instruction manual for a detailed description of the control panels.
3 TECHNICAL DATA
Tig 1500i Tig 2200i/2200iw
Mains voltage 230V, 10%, 1~ 50/60 Hz 230V, 10%, 1~ 50/60 Hz
Mains supply Zmax 0.35 ohm Zmax 0.31 ohm
Primary current
Imax TIG 14 A 24 A
Imax MMA 22 A 25 A
No-load power 30 W 30 W
demand when in the energy-saving
mode, 6.5 min. after welding
Setting range
TIG 3 A - 150 A 3 A - 220 A
MMA 4 A - 150 A 4 A - 170 A
Ignition voltage (Upk) 11.5 kV 11.5 kV
Permissible load at TIG
20% duty cycle 220 A / 18.8 V
25% duty cycle 150 A / 16.0 V
60% duty cycle 120 A / 14.8 V 150 A / 16.0 V
100% duty cycle 110 A / 14.4 V 140 A / 15.6 V
-7-
bt34d1ea © ESAB AB 2013
Duty cycle
The duty cycle refers to the time as a percentage of a ten-minute period that you can weld or cut at
a certain load without overloading. The duty cycle is valid for 40° C.
Enclosure class
The IP code indicates the enclosure class, i. e. the degree of protection against penetration by solid
objects or water. Equipment marked IP23 is designed for indoor and outdoor use.
Application class
The symbol indicates that the power source is designed for use in areas with increased
electrical hazard.
Mains supply, Z max
Maximum permissible line impedance of the network in accordance with IEC 61000-3-11.
-8-
bt34d1ea © ESAB AB 2013
4 INSTALLATION
The installation must be carried out by a professional.
Note
Mains supply requirements
High power equipment may, due to the primary current drawn from the mains supply, influence the
power quality of the grid. Therefore connection restrictions or requirements regarding the
maximum permissible mains impedance or the required minimum supply capacity at the interface
point to the public grid may apply for some types of equipment (see technical data). In this case it
is the responsibility of the installer or user of the equipment to ensure, by consultation with the
distribution network operator if necessary, that the equipment may be connected.
4.1 Location
Position the welding power source such that its cooling air inlets and outlets are not
obstructed.
-9-
bt34d1ea © ESAB AB 2013
5 OPERATION
General safety regulations for handling the equipment can be found on
page 5. Read through before you start using the equipment!
- 10 -
bt34d1ea © ESAB AB 2013
MMA TIG
5.4 TIG-welding
Before using the Tig 1500i/2200i for TIG welding it must be equipped with:
a TIG torch
a cylinder of suitable welding gas
a welding gas regulator (suitable gas regulator)
tungsten electrodes
suitable filler metal, if necessary
5.5 MMA-welding
nection of the
cated on the package of the electrode to be used.
Connect the return cable to the other terminal. Fit the earth clamp of the return cable
to the work-piece and make sure there is good contact between the work-piece and the
return cable terminal on the welding power source.
5.6 Overheating protection
The power source has two thermal overload trips which operate if the internal
temperature becomes too high. A fault code is shown in the panel. They reset
automatically when the temperature has fallen.
- 11 -
bt34d1ea © ESAB AB 2013
6 MAINTENANCE
Regular maintenance is important for safe, reliable operation.
Only those persons who have appropriate electrical knowledge (authorized
personnel) may remove the safety plates to connect or carry out service,
maintenance or repair work on welding equipment.
CAUTION
All guarantee undertakings from the supplier cease to apply if the customer attempts any
work to rectify any faults in the product during the guarantee period.
7 FAULT-TRACING
Try these recommended checks and inspections before sending for an authorised
service technician.
Type of fault Corrective action
No arc. Check that the mains power supply switch is turned on.
Check that the welding current supply and return cables are
correctly connected.
Check that the correct current value is set.
Check the mains power supply.
The welding current is Check to see whether the thermal cut-outs have tripped.
interrupted during welding. Check the mains power supply fuses.
- 12 -
bt34d1ea © ESAB AB 2013
T y pe o f fa u lt C o r r e c ti v e a c ti o n
The thermal cut-out trips Make sure that you are not exceeding the rated data for the
frequently. welding power source (i.e. that the unit is not being
overloaded).
Make sure that the power source is clean.
Poor welding performance. Check that the welding current supply and return cables are
correctly connected.
Check that the correct current value is set.
Check that the correct electrodes are being used.
Check the gas flow.
Tig 1500i, Tig 2200i is designed and tested in accordance with the international and
European standards IEC/EN 60974-1, IEC/EN 60974-3 and IEC/EN 60974-10. It is the
obligation of the service unit which has carried out the service or repair work to make
sure that the product still conforms to the said standard.
Spare parts may be ordered through your nearest ESAB dealer, see the last page of
this publication.
- 13 -
bt34d1ea © ESAB AB 2013
- 14 -
bt34e © ESAB AB 2013
- 16 -
bt34e © ESAB AB 2013
- 18 -
bt34e © ESAB AB 2013
Order number
0460 450 880 Caddy Tig 1500i, TA33 incl. 3 m MMA cable kit complete and Tig torch TXH 150, 4 m
0460 450 881 Caddy Tig 2200i, TA33 incl. 3 MMA cable kit complete and Tig torch TXH 200, 4 m
0460 450 882 Caddy Tig 1500i, TA34 incl. 3 m MMA cable kit complete and Tig torch TXH 150, 4 m
0460 450 883 Caddy Tig 2200i, TA34 incl. 3 m MMA cable kit complete and Tig torch TXH 200, 4 m
0460 450 884 Caddy Tig 2200iw, TA33 incl. water cooler CoolMini, 3 m MMA cable kit complete and
Tig torch TXH 250w, 4 m
0460 450 885 Caddy Tig 2200iw, TA34 incl. water cooler CoolMini, 3 m MMA cable kit complete and
Tig torch TXH 250w, 4 m
0460 450 890 Caddy Tig 1500i, TA33 incl. 3 return cable with clamp
0460 450 891 Caddy Tig 2200i, TA33 incl. 3 return cable with clamp
0460 450 892 Caddy Tig 1500i, TA34 incl. 3 return cable with clamp
0460 450 893 Caddy Tig 2200i, TA34 incl. 3 return cable with clamp
0460 450 894 Caddy Tig 2200iw, TA33 incl. 3 return cable with clamp
0460 450 895 Caddy Tig 2200iw, TA34 incl. 3 return cable with clamp
0460 447 074 Instruction manual Control panel, Caddy TA33, TA34
0459 839 125 Spare parts list Welding power source, Tig 1500i, Tig 2200i, Tig 2200iw
Instruction manuals and the spare parts list are available on the Internet at www.esab.com
- 20 -
bt34o © ESAB AB 2013
Accessories
Trolley . . . . . .
for 5-10 litre gasbottle . . . . . . . . . . . . . . . . . . . . . 0459 366 885
Trolley
for 20-50 litre gasbottle . . . . . . . . . . . . . . . . . . . . 0459 366 887
Trolley
for 20-50 litre gasbottle . . . . . . . . . . . . . . . . . . . 0460 330 880
- 21 -
bt34a11a © ESAB AB 2013
Tig torch
TXH 150 4 m . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0700 300 538
TXH 150 8 m . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0700 300 544
TXH 200 4 m . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0700 300 552
TXH 200 8 m . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0700 300 555
TXH 250w 4 m . . . . . . . . . . . . . . . . . . . . . . . . . . . 0700 300 561
TXH 250w 8 m . . . . . . . . . . . . . . . . . . . . . . . . . . . 0700 300 563
Tig torch
TXH 150r 4 m . . . . . . . . . . . . . . . . . . . . . . . . . . . 0462 011 842
TXH 150r 8 m . . . . . . . . . . . . . . . . . . . . . . . . . . . 0462 011 882
TXH 200r 4 m . . . . . . . . . . . . . . . . . . . . . . . . . . . 0462 012 840
TXH 200r 8 m . . . . . . . . . . . . . . . . . . . . . . . . . . . 0462 012 880
TXH 250wr 4 m . . . . . . . . . . . . . . . . . . . . . . . . . . 0462 013 840
TXH 250wr 8 m . . . . . . . . . . . . . . . . . . . . . . . . . . 0462 013 880
- 22 -
bt34a11a © ESAB AB 2013
- 23 -
bt34a11a © ESAB AB 2013
www.esab.com
© ESAB AB 110915
Downloaded from www.Manualslib.com manuals search engine