EVERYTHING T O C R E AT E Y O U R

BESTCRETE DECORATIVE BLOCKS AND PAVERS

 CAPSTONE
Secure your property on any slope. Get stylish, rock-solid
stability to keep your land safely in one place.

SPECIFICATIONS:
- 98mm H x 392mm W x 294mm D
(Nominal size: 4” H x 16” W x 12” D)
- Weight: 51lbs (23.2kg)

LANDSCAPING &
RETAINING WALL
SOLUTIONS

ALLAN BLOCK ALLAN BLOCK JUMBO JUNIOR CALIFORNIA SPLIT

Transform your yard from plain to picture-perfect! The smaller, lightweight version of the versatile The rugged face of the California split block enables
Create spectacular terraces, planters and patios Allan Block. Make an impression with terraced you to create visually appealing, rustic appearance for
– all without mortar! gardens, graceful entrances, raised planters perimeter walls and building facings.
and more – the possibilities are endless.
SPECIFICATIONS: SPECIFICATIONS:
- 196mm H x 441mm W x 294mm D SPECIFICATIONS: - 92mm H x 92mm W x 397mm D
(Nominal size: 8” H x 18” W x 12” D) - 194mm H x 222mm W x 244mm D (Nominal size: 4” H x 4” W x 16” D)
- Weight: 80.5lbs (36.53kg) (Nominal size: 8” H x 9” W x 10” D) - Weight: 18.5lbs (8.4kg)
- Weight: 35lbs (15kg)
 Upscale Appeal CATALINA STONE
The rugged face of the
Catalina split block enables
you to create a visually
appealing, rustic appearance
ARCADIAN
SPECIFICATIONS:
- 92mm H x 397mm W x 143mm D
(Nominal size: 6” H x 16” W x 6” D)
- Weight: 17.6lbs (8kg)
for perimeter walls and
building facings.

6 INCH
SPECIFICATIONS:
PARADE
DECORATIVE - 194mm H x 397mm W x 143mm D
(Nominal size: 8” H x 16” W x 6” D) HALF HEIGHT

BLOCKS - Weight: 34.2lbs (15.5kg)

SPECIFICATIONS:
- 92mm H x 397mm W x 194mm D
(Nominal size: 4” H x 16” W x 8” D)
8 INCH
- Weight: 16.1lbs (7.3kg)
SPECIFICATIONS:
- 194mm H x 397mm W x 194mm D
(Nominal size: 8” H x 16” W x 8” D)
- Weight: 40.6lbs (18.4kg)

HARLEQUIN
SPECIFICATIONS:
- 92mm H x 397mm W x 143mm D
(Nominal size: 4” H x 16” W x 6” D)
- Weight: 16.5lbs (7.5kg)
 BRICK
SPECIFICATIONS:
- 60mm H x 198mm W x 100mm D
(Nominal size:
2 3/8” H x 8” W x 4” D)

Redefined
- Weight: 5.63lbs (2.55kg)

Number of pavers required

= L” x W” x 4.4 DESIGN

PAVING Create stunning surroundings

SOLUTIONS that last a lifetime! Versatile, low
maintenance and easy to install,
these interlocking paving stones
TRI HEX can transform driveways, patios
SPECIFICATIONS:
and walkways into surfaces that
- 80mm H x 186mm W x 92mm D
(Nominal size: make a distinctive statement.
3 5/32” H x 7 5/16” W x 3 5/8” D)
- Weight: 8.63lbs (3.87kg)
DUO
Number of pavers required
= L” x W” x 4 PIECE A PIECE B
SPECIFICATIONS: SPECIFICATIONS:
- 60mm H x 158mm W x 158mm D - 60mm H x 158mm W x 238mm D
(Nominal size: (Nominal size:
2 23/64” H x 6 7/32” W x 6 7/32” D) 2 23/64” H x 6 7/32” W x 9 3/8” D)

Combined Weight: 16.5lbs (7.5kg) B A

Number of pavers required = L” x W” x 1.5
GRASS PATHWAY
Enjoy the best of both worlds! Grass Pavers SPECIFICATIONS:
allow you to perfectly combine the natural - 60mm H x 398mm W x 398mm D
beauty of grass and the strength of concrete. (Nominal size:
For driveways, parkways or any area where 2 23/64” H x 15 43/64” W x 15 43/64” D)
greenery is desired, they’re the ideal choice. - Weight: 47.4lbs (21.5kg)

SPECIFICATIONS: Number of pavers required

- 92mm H x 584mm W x 438mm D = L” x W” x 0.6
(Nominal size: 4” H x 23” W x 17 1/4” D)
- Weight: 63lbs (28.6kg)

Number of pavers required

= L” x W” x 0.36

TROPIC-I WOODGRAIN
SPECIFICATIONS:
SPECIFICATIONS:
- 40–45mm H* x 200mm W x 600mm D
- 80mm H x 197mm W x 143mm D
(Nominal size:
(Nominal size: 3 5/32” H x 7 3/4” W x 5 5/8” D)
1 37/64”–1 49/64” H* x 7 7/8” W x 23 5/8” D)
- Weight: 9.63lbs (4.35kg)
- Weight: 25.3lbs (11.5kg)
Also available in 2 3/8” (60mm) height.
Number of pavers required
- Weight: 7lbs (3.17kg)
= L” x W” x 0.8
Number of pavers required
= L” x W” x 3.8

*Height varies because of the

uneven surface.
 I N T E R LO C K I N G PAV E R S
INSTALLATION INSTRUCTIONS

1| Measure the area to be paved (L x W). To determine the number of pavers required, multiply the area by the paver factor shown below.

NUMBER OF PAVERS REQUIRED

PAVERS SPECIFICATIONS
(AREA x PAVER FACTOR)

2 3/8” H x 8” W x 4” D
BRICK (60mm H x 198mm W x 100mm D)
L x W x 4.4

A: 2 23/64” H x 6 7/32” W x 6 7/32” D

(60mm H x 158mm W x 158mm D)
DUO L x W x 1.5
A B: 2 23/64” H x 6 7/32” W x 9 3/8” D
B (60mm H x 158mm W x 238mm D)

4” H x 23” W x 17 1/4” D
GRASS (92mm H x 584mm W x 438mm D)
L x W x 0.36

2 23/64” H x 15 43/64” W x 15 43/64” D

PATHWAY (60mm H x 398mm W x 398mm D)
L x W x 0.6

3 5/32” H x 7 5/16” W x 8” D
TRI HEX (80mm H x 186mm W x 92mm D)
LxWx4

3 5/32” H x 7 3/4” W x 5 5/8” D

TROPIC-I (60–80mm H x 197mm W x 143mm D)
L x W x 3.8

1 37/64”–1 49/64” H* x 7 7/8” W x 23 5/8” D

WOODGRAIN (40–45mm H x 200mm W x 600mm D) L x W x 0.8
*Height varies because of the uneven surface.
2| Determine the thickness of the base required for your application
from Table 1. This, together with the area, will determine the volume
4| Install edge restraints. Adequate interlocking stability cannot be
achieved without sufficient edge restraints such as kerb walls or
of fill material required. Sharp sand to a depth of 2 inches must be paver edge restraints.
placed after the fill material has been laid. The depth of excavation
is dependent on the finished level.
5| Place and compact the base material in 2 inch lifts (the material
may not compact properly if it is too dry). The finished base should
be relatively smooth and flat. During the laying of the base, a
3| Excavate for your base. The soil is often compacted using a roller
or plate compactor. The depth of the base will be determined by the
slight slope or grade of ¼ - ½ inch in every foot should be created TABLE 1: GUIDELINES FOR CONCRETE
so that water runs off and does not settle. MASONRY PAVING UNITS
depth of the fill material needed, the layer of sharp sand and the
thickness of the paver.

6| Lay a sheet of polythene on the compacted base. The 2 inch sharp

sand layer should then be placed on this sheet and compacted.
APPLICATION
(Well Drained Conditions)
THICKNESS
OF BASE
This layer must be screeded, ensuring that the slope created in
concrete pavers Step 5 is maintained. The area should not be disturbed after it
• Patios
finished grade of pavers has been levelled. Ensure that the sand is kept dry throughout
• Residential Walkways
0-3 inches
60mm
existing ground level
2in the process. • Residential Driveways
(varies)
and Parking

7| Starting from one side, begin placing pavers along the edge
restraints. These should be laid to the specific pattern, with each
bedding sand
unit flush to the adjacent units. Guidelines should be used to • Sidewalks
compacted aggregate base
ensure that pavers are placed in a straight line. • Residential Streets 4-6 inches
compacted soil
• Public Parking
PARTIAL CROSS SECTION:
Kerb Detail Diagram
8| When the laying of pavers is complete, a fine sand is swept over
the area into the joints. The pavers should now be vibrated to their • City Streets
final level with a plate compactor. The excess sand is then swept • Gas Stations
from the pavement. 8 inches
• Loading Ramps
• Industrial Floors

As in all natural materials, colour in paving stones has inherent variations. NOTE: Only clean or washed sharp sand should be used. Do not use
Paver colour may vary slightly due to several factors inclusive of the source highly organic sharp sand as this may cause paver discolouration. NOTE: The sand base between the base and the concrete
of raw materials, climatic conditions and the presence of moisture. Use a masonry cutting disc to cut pavers where necessary. paving units is always made 2 inches thick. We recommend
using Bestcrete aggregates only.
 CUSTOMISABLE FREQUENTLY ASKED QUESTIONS

WHAT DEPTH OF PAVING BLOCK DO I REQUIRE? CAN PAVERS BE USED AROUND TREES AND
OTHER OBJECTS?
• 60mm - Suitable for any driveway or domestic
Customise your order with various colours. Speak with application (domestic driveway – busy use). • Yes, pavers can be used around trees. Pavers can
one of our representatives for more information. also be cut to fit and curve around any object.
• 80mm - Suitable for commercial applications
where there are very high volumes of traffic.

CAN BROKEN OR CRACKED PAVERS

Concrete Charcoal Baked BE REPLACED?
Grey Grey Terracotta
DO I NEED MORTAR TO INSTALL THE PAVERS?
• Yes, they can be easily removed either by hand or
• No, the materials needed to install the pavers with simple tools like screwdrivers. A new paver
are an aggregate base, fine and sharp sand and can be inserted, the fine sand replaced between
sheets of polythene. joints, and then the paver compacted into place
with a rubber mallet.

CAN WEEDS GROW THROUGH THE JOINTS?

HOW DO I MAINTAIN MY PAVERS?
• The compacted process of laying pavers prohibits • Pavers are made from natural materials. Regular
growth of weeds. However, it is possible for seeds sweeping and pressure washing is recommended.
Desert Sand Stone
Mauve to become lodged between joints via the wind and However, your pavers should not be forced to
animals. Regular sweeping can prevent this. regularly withstand more weight and rougher
The spraying of pesticides can also remove the uses than their intent.
weeds and prevent further growth, as well as just
pulling them out.
HOW LONG WILL THESE PAVERS LAST?
• Paving stones can last for more than 50 years.
www.buildwithabs.com (868) 62-BUILD