Component Identifiers (CID¹) Wire Description Component Location

Module Identifier (MID²) Wire Wire

Description
Wire Wire
Description Schematic Machine Schematic Machine
RENR7307-02 Harness And Wire Electrical Schematic Symbols
Number Color Number Color
Component
Location Location
Component
Location Location July 2008
Engine Control System Power Circuits Lighting Circuits Cont. Symbols
A/C Unit I-8 A Sensor - Fuel Temperature B-15 H
(MID No. 036) 101 RD Bat (+) 638 WH Rotary Beacon
Alarm - Action F-2 A Sensor - Intake Manifold Air Temperature C-16 H
CID Component 102 BU Hd Lmp 645 RD Headlamp Relay
Alarm - Travel B-11 1 Sensor - Intake Air Pressure C-16 H
0001 Injector Cylinder 1 103 RD ET CONN / Dome Lamp / Monitor / Radio / Service Meter 646 RD Light Sw To Front Flood Relay
Alternator H-18 2 Sensor - Pump Pressure C-14 24
0002 Injector Cylinder 2 105 RD Key Sw 684 RD Cab Flood Lamp T
Bateries I-18 D Sensor - Speed H-18 25
0003 Injector Cylinder 3 109 RD Alt Output (+) Term. A623 BU Right Cab Flood Lamp Sw To Relay
Breaker - Alternator / Start Relay H-15 D Sensor - Swing Pump Pressure C-14 26
Pressure Temperature Level Flow Circuit Breaker
110 RD Timer Relay Control Circuits
0004 Injector Cylinder 4 Control - Engine F-18 H Symbol Symbol Symbol Symbol Symbol
112 PU Main Power Rly Output 709 OR Sensor Power Supply
0005 Injector Cylinder 5 Control - Gateway Worldview H-6 4 Sensor - Water Seperator Level F-15 8
113 OR Monitor Panel B+ Switched 788 YL Eng Speed (+)
0006 Injector Cylinder 6 114 RD Warning Horn (forward) A755 PK Throttle Sw #1 Control - Valve E-8 6 Service Meter E-2 A Symbols and Definitions
0091 Throttle Position Switch 115 RD Cab Lamp Relay A756 BU Throttle Sw #2 Control - Wiper E-2 A Solenoid - A/C Clutch H-18 F
0094 Fuel Pressure Sensor 118 GY Wiper Control A757 GY Throttle Sw #3 Control Handle - LH K-2 C Solenoid - Auto Reverse Fan A-13 9 Fuse: A component in an electrical circuit that will open the circuit if too much current flows
0100 Engine Oil Pressure Sensor 120 YL Converter A758 BR Throttle Sw #4 Control Handle - RH J-1 B Solenoid - Boom Anti-Drift A-14 F through it.
0102 Boost Pressure Sensor 123 WH Seat Heater Switch A768 BU Pump Control Valve #1 (+) Converters - 12v 7A H-7 5 Solenoid - Boom Extend A-10 F
0110 Engine Coolant Temperature Sensor 124 GN A/C Unit Switched B+ E789 PU Hex Machine Cntl Sol Return #1 Diode - Backup (1) I-13 D Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
Solenoid - Boom Retract B-14 F
125 RD A/C Unit E790 PK Hex Machine Cntl Sol Return #2 circle indicates that the component has screw terminals and a wire can be disconnected from it.
0168 System Voltage Diode - Backup (2) I-13 D Solenoid - Bucket Extend A-10 F
127 OR Air Suspension F716 WH Shutdown
0172 Intake Manifold Air Temperature Sensor Diode - Backup (3) L-10 D Solenoid - Bucket Retract B-14 F
129 BU Cigar Lighter F717 YL Throttle Backup (Accelerate)
0174 Fuel Temperature Sensor Diode - Backup (4) K-11 D Solenoid - Counter Weight Removal Control C-15 29 Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
130 RD Implement / Valve Control F718 BU Throttle Backup (Decelerate)
0190 Engine Speed Sensor Diode - Chassis Lamp K-16 D Solenoid - Extend A-10 F No circle indicates that the wire cannot be disconnected from the component.
131 RD Implement / Valve Control H704 PK Impl Cont Reversing Fan Sol
0248 Cat Data Link 135 BU Converter Output (24/12 Volt) H716 WH Impl Cont Sol Return Diode - Main Relay K-16 D Solenoid - Hydraulic Lock A-13 F
0261 Engine Timing/Calibration 139 OR Radio Mute Sw. H733 BU Hex Backup Pump Resistor To Diode Diode - Refueling Relay B-6 18 Solenoids - Injectors 1 - 6 D-16 H Ground (Wired): This indicates that the component is connected to a grounded wire. The
0262 5 Volt DC Supply 140 BU Auto Lube Circuit M732 OR MSS Relay 2 Diode - Start Relay J-13 D Solenoid - LH Front Travel B-10 F grounded wire is fastened to the machine.
0268 Programable Parameters 147 PU Pump & OLWD Sensor Power M733 PK MSS Relay 1 Fuse Block K-15 D Solenoid - LH Rear Travel B-14 F
0274 Atmosphereic Pressure Sensor 148 WH Boom Lamp Relay 2 X738 PK Return Filter Sw. To Controller Indicator Unit I-1 B Solenoid - LH Swing B-8 F Ground (Case): This indicates that the component does not have a wire connected to ground.
149 PU Boom Lamp Relay 1 801 PK Auto Lube Relay Joystick - LH L-3 C Solenoid - Lowering Check Boom A-11 F It is grounded by being fastened to the machine.
0291 Engine Cooling Fan Solenoid
150 RD Neutral Start Limit Switch 892 BR Cat Data Link (-) Joystick - RH J-2 B Solenoid - Lowering Check Stick A-11 F
0342 Secondary Engine Speed Sensor
151 GN Neutral Start Limit Switch 893 GN Cat Data Link (+) Monitor F-1 A Solenoid - Neutral Flow Bypass A-14 F Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
2417 Start Aid Solenoid
154 RD Neutral Start Limit Switch F853 BR Travel Speed contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Motor - A/C Condenser E-15 11 Solenoid - PS Pressure A-13 F

365C Excavator
Implement / Pump Control System 160 PU Chassis Lamp Relay F856 GN Boom Valve Driver
Motor - Auto Lube Pump C-4 14 Solenoid - Radiator Fan Speed Control C-14 30
(MID No. 039) 168 RD Refueling Power Relay Power F859 GY Backup Resistor - Boom
Motor - ELE Lube Pump C-4 15 Solenoid - Retract A-14 F Sender: A component that is used with a temperature or pressure gauge. The sender
172 RD Gateway Worldview Module / MSS / Product Link F874 PK Switch To Timer Input
measures the temperature or pressure. Its resistance changes to give an indication to

& 365C Front Shovel

CID Component Motor - Refueling Pump B-6 18 Solenoid - RH Front Travel B-10 F
175 RD A/C Unit F889 WH Throttle Position Feedback T
0096 Fuel Level Sender Motor - Starter G-18 12 Solenoid - RH Rear Travel B-14 F the gauge of the temperature or pressure.
176 YL Aux Ckt H807 YL On/off Driver Return (1-8)
0110 Engine Coolant Temperature Sensor 179 BU Converter K847 PU Stem 3 Retract Switch Motor - Washer I-11 13 Solenoid - RH Swing B-8 F

Electrical System
0190 Engine Speed Sensor 180 GN Aux Ckt K848 WH Stem 4 Retract Switch Motor - Wiper J-1 A Solenoid - Start Aid F-15 31 Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
0291 Engine Cooling Fan Solenoid 196 BU Aux Ckt L885 BU Switch Panel Option Switch Pedal - Center K-1 G Solenoid - Stick Anti-Drift B-10 F It has a coil that makes an electromagnet when current flows through it. The
0295 Control Module 199 OR Action Alarm / Beacon Relay L886 BR Switch Panel Option Switch Pedal - LH K-1 G Solenoid - Stick Extend A-10 F electromagnet can open or close the switch part of the relay.
0374 Swing Brake Solenoid Ground Circuits L887 PK Switch Panel Option Relay Pedal - RH K-1 G Solenoid - Stick Retract B-14 F
0376 Travel Alarm 200 BK Main Chassis 998 BR Digital Sensor Return Relay - Auto Lube J-13 D Solenoid - Swing Brake D-10 F Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
0379 Auto-Lube Pressure Sensor 210 BK Converter Output (24/12 Volt) C904 GN MSS Relay 2 Relay - Beacon K-11 D Solenoid - Swing Pump Swash C-14 32 ELC1-UP coil that makes an electromagnet when current flows through it. The electromagnet
229 BK Bat (-) E997 BR Hydraulic Lock can open or close a valve or move a piece of metal that can do work.
0466 Left Track Steering Pedal Position Sensor
235 BK Electronic Pump Ctrl Gnd E998 YL Radiator Fan Solenoid
Relay - Boom Lamp Relay (1)
Relay - Boom Lamp Relay (2)
H-16
H-16
D
D
Solenoid - System Pressure
Solenoid - Travel Speed Shift
B-11
A-13
F
F
MEM1-UP
0467 Right Track Steering Pedal Position Sensor
0485 Engine Fan Reversing Solenoid
251
261
YL
GN
CAN Data Link (-)
CAN Data Link (+)
G976
K907
BU
BU
Water Separator Sensor
Swing Brake Sol
Relay - Cab Lamp J-16 D Switch - Air Cleaner F-15 33 FEN1-UP Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
Relay - Chassis Lamp K-16 D Switch - Aux 1 Way / 2 Way Limit (1) C-11 10 activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
0558 Auto-Lube Relay
0586 Engine Speed Dial Switch 304 WH
Basic Machine Circuits
Starter Relay No. 1 Output
K909
K924
BU
YL
Backup Sw
Safety Lock Solenoid
Relay - Horn J-16 D Switch - Aux 1 Way / 2 Way Limit (2) C-11 16 PAR1-UP that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.
0588 Monitoring System Display 306 GN Starter Relay Coil To Neut Start Sw Or Key Sw K927 BU Solenoid Return 1 Relay - Hydraulic Lock Solenoid
Relay - Lamp Delay Timer
J-16
L-13
D
D
Switch - Backup Boom
Switch - Backup EPR Valve
J-3
H-3
C
B
MCS1-UP
0590 Engine Control Module 307 OR Key Sw To Neutral Start Sw Or Vmis Sensor Module K928 GN Stick Sol Retract
0598 Travel Speed Solenoid 308 YL Main Power Relay Coil K929 GN Bucket Sol Retract Relay - Main K-14 D Switch - Backup Governor H-2 B MCY1-UP Harness and Wire Symbols
310 PU Start Aid Sw To Start Aid Sol K930 GN Swing Sol Extend Relay - MSS (1) J-13 D Switch - Coolant Level F-15 37
0600 Hydraulic Oil Temperature Sensor
317 YL Start Aid Relay To Start Aid Sol K931 GN Bucket Sol Extend Relay - MSS (2) K-13 D Switch - Counter Weight Removal C-15 38 1 Deutsch connector: Typical representation Sure-Seal connector: Typical representation
0790 Swing Pump (Outlet)Pressure Sensor 1
320 RD Horn Relay Coil To Sw K932 BU Swing Sol Left Relay - Neutral Start I-16 D Switch - Disconnect H-16 D of a Deutsch connector. The plug contains all of a Sure-Seal connector. The plug and receptacle
0864 Variable Implement Hydraulic Pump Pressure Sensor
321 BR Backup Alarm Lamp Travel Alarm K934 BR Swing Sol Right
2 sockets and the receptacle contains all pins. 2 contain both pins and sockets.
Relay - Refueling (1) A-6 18 Switch - Engine Oil Level H-18 39
1118 Neutral Flow Bypass Solenoid 322 GY Warning Horn (forward) K943 OR Travel Left Sol Rear Relay - Refueling (2) B-6 55 Switch - Fuel Differential Pressure B-15 H Harness Identification Letter(s):
1119 Boom Anti-Drift Solenoid 323 WH Fuel Pump Power K944 YL Travel Left Sol Front Wire, Cable, or Harness Assembly Identification:
Relay - Refueling Power B-6 54 Switch - Horn K-3 C (A, B, C, ..., AA, AB, AC, ...)
1120 Stick Anti-Drift Solenoid 325 PK Fuel Pump Relay Cut-out K945 GY Resistor To Left Backup Sw Includes Harness Identification Letters and Harness
Relay - Start I-11 D Switch - Hydraulic Oil Filter (1) A-7 E Connector Serialization Codes Harness Connector Serialization Code: The "C" stands
1121 Front System High Pressure Solenoid 329 YL Fuel Pump To Sw K946 OR Travel Right Sol Rear for "Connector" and the number indicates which
Relay - Start Aid I-16 D Switch - Hydraulic Oil Level B-7 E
1125 Left Hand Lever Forward/Backward Position Sensor 365 YL Fuel Pump Relay To Switch K947 YL Travel Right Sol Front connector in the harness. (C1, C2, C3, .....)
Relay - Timer L-16 D Switch - Key H-1 B Part Number for
1126 Left Hand Lever Left/Right Position Sensor A346 BU MSS Relay 2 K948 GY Resistor To Right Backup Sw C-C4 AG-C3 Connector Plug AG-C4 L-C12 Part Number For
Resistor - Backup LH Travel L-10 D Switch - LH Backup Travel J-3 C 111-7898 3E-5179 Connector Recepticle
1127 Right Hand Lever Forward/Backward Position Sensor A347 GN MSS Relay 1 K949 OR Boom Retract Sol 130-6795 130-6795
Monitoring Circuits K950 YL Boom Extend Sol Resistor - Backup RH Travel K-10 D Switch - Manual Lube D-3 A
1128 Right Hand Lever Left/Right Position Sensor 325-AG135 PK-14 1 5A
403 GN Alternator (r) Term. K951 GY Resistor To Boom Backup Sw Resistor - Boom Backup L-11 D Switch - Neutral Start Limit L-3 C
1129 Right Side Attachment Pedal Sensor Pin Socket
405 GY Oil Press. (low Setting) K952 BR Sol Return 3 Resistor - Boom Down Backup L-16 D Switch - OLWD Warning Device D-4 A Receptacle Fuse
1130 Left Side Attachment Pedal Sensor Resistor - CAN E-8 6 Switch - One Touch Low Idle J-2 B Pin or Socket (5 Amps)
410 WH Action Alarm L919 YL Manual Lube Sw Single Wire 9X-1123
1131 Joystick Switch # 1 Number
412 BU Coolant Level Sw. L972 BU Low Idle Sw Resistor - CAN E-1 A Switch - Radio Mute D-3 A Connector
Component
1132 Joystick Switch #4 430 BU Opr Mon Air Filter L976 GN Excavator Fuel Pump Switch Sender - Hydraulic Oil Temperature A-7 E Switch - Refueling Level C-6 40 Plug Part Number
1138 Boom Cylinder Rod Retract Solenoid 487 OR Hyd Oil Flow Sw L982 PK Counterweight Removal Control Solenoid Sensor - Atmospheric Pressure D-16 H Switch - Refueling Start A-4 56 Harness identification code: 2 200-L32 BK-14
1139 Stick Cylinder Rod Extend Solenoid 491 PK Hyd Oil Temp Sensor M933 PU Swing Sol Return Sensor - Auto Lube Pressure C-4 56 Switch - Refueling Stop A-4 3 This example indicates wire
495 GN Fuel Level Signal M935 BU PS Press Sol To Backup Resistor 135 in harness "AG".
1140 Stick Cylinder Rod Retract Solenoid Sensor - Boom OLWD Pressure C-6 7 Switch - RH Backup Travel H-3 B Ground Circuit Identification
496 WH Hyd Oil Level M937 GN Flow Control Prox Sw#1 To Abl Connection Number Wire Color Wire Gauge
1141 Bucket Cylinder Rod Extend Solenoid Sensor - Camshaft Speed C-16 H Switch - Seat Heater D-4 A
497 OR Sensor Power (not used) M938 GY Flow Control Prox Sw#2 To Abl
1142 Bucket Cylinder Rod Retract Solenoid Sensor - Crankshaft Speed C-16 H Switch - Secondary Shutdown L-1 17
1143 Swing Right Solenoid
C468 BU Engine Oil Level M942 WH Lever Top Sw (lh-r)
Sensor - Engine Coolant Temperature C-16 H Switch - Throttle Position I-1 B © 2008 Caterpillar Printed in U.S.A.
C472 GN Front Pump Press M943 YL Lever Top Sw (lh-l)
1144 Swing Left Solenoid E456 WH Autolube Pressure M944 BU Lever Top Sw (rh-r)
Sensor - Engine Oil Pressure C-16 H Switch - Under Window Limit E-3 A All Rights Reserved
1145 Attachment Extend/CW Solenoid E480 WH Overload Warning Device Sw. M945 BR Lever Top Sw (rh-l) Sensor - Fuel Level B-7 22 Switch - Window Limit G-2 A
1146 Attachment Retract/CW Solenoid G426 WH Swing Pressure M947 OR LH Joystick Sensor - Fuel Pressure B-15 H Switch Panel E-1 A
1147 Medium Pressure Circuit #1-A Solenoid H441 GN Stick Lube Pressure M948 BR LH Joystick Machine locations are repeated for components located close together.
1148 Medium Pressure Circuit #1-B Solenoid H446 PK Boom Lower Check Pressure Sensor M949 PK LH Joystick A = Located inside of cab.
1149 Boom Lowering Check/Modulation Valve Solenoid Accessory Circuits M950 PU LH Joystick B = Located inside of right console.
500 BR Wiper - Front (park) M953 BU LH Joystick
1150 Swing Pump Swash Plate Angle Solenoid C = Located inside of left console.
501 GN Wiper - Front (low) M954 BU Hammer Pedal
1155 Implement Pump Power Shift Pressure Solenoid D = Located around relay panel.
506 PU Washer - Front M956 GN Travel Pedal
1159 Stick Lowering Check/Modulation Valve Solenoid E = Located around hydraulic oil tank.
508 PU Radio Speaker - Left M957 GY Travel Pedal
1160 Hydraulic Lock Solenoid 509 WH Radio Speaker - Left (commom) M960 PU Straight Travel Pedal F = Located around pilot manifold.
1163 Left Travel Backward Solenoid 511 BR Radio Speaker - Right M962 YL RH Joystick G = Located under platform.
1164 Right Travel Backward Solenoid
Connector Location
512 GN Radio Speaker - Right (common) M963 BU RH Joystick H = Located on the engine. Off Machine Switch Specification
1165 Right Travel Forward Solenoid 514 PU A/c Condensor Motor N957 PK Rxd - Comm #1 Schematic Machine
Connector Number Part No. Function Actuate Deactuate Contact Position
1166 Left Travel Forward Solenoid 530 OR Washer Right N959 PK Rxd - Comm #3 Location Location
590 GY Wiper Sw To Intermittent Module N960 OR Txd - Comm #1 CONN 1 E-17 H 162-6208 Air Cleaner 635 ± 58 mmH2O Normally Open
1178 Machine Overload Warning Pressure Sensor
592 BU Dc/dc Converter Power Output N963 OR Txd - Comm #3 CONN 2 B-16 H
1191 Main Hydraulic Valve
A513 RD Dc/dc Converter Memory Output N970 YL Dtr - Comm #1 CONN 3 TDC PROBE D-16 H
1192 Swing Hydraulic Valve
A537 PK Seat Heater N973 BR Dcd - Comm #1 CONN 4 E-16 19
1193 Boom Cylinder Rod Extension Solenoid
A579 OR Wiper Motor + N979 GN Signal Gnd - Comm #1
1657 Left Joystick Thumbwheel A CONN 5 E-16 19
A580 BR Wiper Motor - N981 GN Signal Gnd - Comm #3
1658 Right Joystick Thumbwheel CONN 6 F-16 19
A584 BU Front Window Limit Sw To Wiper Cont P943 GN Stick Lowering Sol 5
¹ The CID is a diagnostic code that indicates which circuit is faulty. 16 10 C CONN 7 F-16 19

(Dimensions: 39 inches x 24 inches)

A586 OR Wiper Sw To Wiper Cont P944 GY Boom Lowering Sol
² The MID is a diagnostic code that indicates which electronic control module C506 WH Hi Relay P945 OR Anti Drift Sol- Stick 24 2 30 12 F 33 40 CONN 8 H-16 D
11 B CONN 9 K-16 D
diagnosed the fault. C560 OR Left Rear Speaker P946 BR Anti Drift Sol- Boom
32 26 28
C566 PK Left Rear Speaker (common) P949 PU Sys Press Up Sol- Front
H D CONN 10 G-14 D
C569 YL Second Dc/dc Converter Power Output P955 BU Neutral Flow Bypass Sol #2 31 E 4 CONN 11 D-14 38
22 3 56
E554 PK A/C Controller To A/C Compressor Clutch P957 BR Att Extend Sol
29 25 37 CONN 12 C-13 20 Resistor, Sender and Solenoid Specifications
Lighting Circuits P958 PK Att Retract Sol 39 27 9 8 1 23 6 CONN 13 C-12 20 Part No. Component Description Resistance (Ohms)¹
603 PK Rotary Beacon P959 GN Swing Pump Swash Sol 38 20 15 54 18 55

RENR7307-02
Failure Mode Identifiers (FMI)¹ 13 21 G CONN 14 C-12 20 111-9916 Solenoid: PS Pressure 11.7 ± 1.2
607 PK Flood Lamp - Front T901 YL MSS Exciter Coil In 19
14 7 17 CONN 15 C-11 20 Swing LH
FMI No. Failure Description 615 YL Cab Flood Lamp / Rops T902 PK MSS Exciter Coil Out 112-5874 Solenoid: 6.5 ± 0.4
CONN 16 G-13 D Swing RH
0 Data valid but above normal operational range. 616 BU Bucket Flood Lamp/boom Flood Lamp X976 BU Backup Diode 1 to Backup Diode 2
CONN 17 G-13 D Hydraulic Lock
633 BU Attach Lighting Ckt X977 YL Boom Down Backup Resistor to Backup Diode 2
1 Data valid but below normal operational range. 121-1491 Solenoid: Travel Speed Shift 32 ± 3.2
CONN 18 G-11 D
2 Data erratic, intermittent, or incorrect. Swing Brake
CONN 19 G-11 D
3 Voltage above normal or shorted high. 126-2941 Resistor: Boom Down Backup Positions 1 thru 4 : 25 ± 5%
CONN 20 G-10 D
4 Voltage below normal or shorted low. CONN 21 C-10 21 Positions 1 thru 3 : 10.7 ± 5%
145-3084 Resistor: Boom Backup
5 Current below normal or open circuit. CONN 22 C-9 21 Position 4: 55 ± 5%
6 Current above normal or grounded circuit. Travel RH Rear
CONN 23 C-9 21
Travel LH Rear
7 Mechanical system not responding properly. CONN 24 C-8 21
Stick Retract
8 Abnormal frequency, pulse width, or period. CONN 25 F-8 23
Boom Retract
9 Abnormal update. CONN 26 F-8 23
Bucket Retract
10 Abnormal rate of change. CONN 27 G-9 23 Retract
11 Failure mode not identifiable. CONN 28 G-9 23 148-2350 Solenoid: Travel RH Front 5 ± 0.3
12 Bad device or component. CONN 29 G-9 6 Travel LH Front
CONN 30 G-9 6 Stick Extend
13 Out of calibration.
Related Electrical Service Manuals CONN 31 K-8 6 Boom Extend
14 Parameter failures.
Title Form Number CONN 32 I-8 6 Bucket Extend
15 Parameter failures.
Alternator: 235-7133 DENSO HDB SENR4130 CONN 33 A-8 27 Extend
16 Parameter not available.
31 13 D CONN 34 C-7 7 151-9360 Resistor:
Backup Travel LH
10.7 ± 5%
17 Module not responding. Electric Starting Motor: 237-1962 DELCO 50MT SENR3860
37 5 C CONN 35 A-5 18 Backup Travel RH
18 Sensor supply fault. Engine Control: RENR5092 11 0% = 83.5 ± 1.5
17 CONN 36 B-5 18
19 Condition not met. Gateway Worldview Module RENR7945 8 A G CONN 37 B-5 55
163-6700 Sender: Fuel Level 50% = 33.8 ± 2.0
20 Parameter failures. 100% = 8 (+1) (-0.5)
Implement and Pump Control: RENR8067 CONN 38 B-5 55

20 Page,
¹The FMI is a diagnostic code that indicates what type of failure has occurred.
6 Lowering Check Boom
Monitor System: RENR8068 B CONN 39 C-6 28 171-0028 Solenoid: 11.5 ± 0.5
2 39 33 Lowering Check Stick
4 CONN 40 ET CONN D-5 A
174-3016 Resistor: CAN Data Link 120 ± 12
23 CONN 41 F-5 A
20 21 CONN 42 G-5 A
Boom Anti-Drift
Neutral Flow Bypass
1 CONN 43 G-4 A 189-0189 Solenoid: 32.6 ± 1.6
32 H 9 10 7 System Pressure
CONN 44 G-3 A Stick Anti-Drift
Event Codes 25 12 CONN 45 H-4 B 239-1134 Solenoid: Start Aid 20
F CONN 46 I-4 B
Engine Control 242-6880 Solenoid: Auto-Reverse Fan 32 ± 3.2
24 26 30 CONN 47 I-4 B
Event Code Condition
16 ¹ At room temperature unless otherwise noted.
19 CONN 48 J-4 B
E172 High Air Filter Restriction 28 22
29 E 14 CONN 49 K-5 C
E265 User Defined Shutdown CONN 50 L-5 C
27 40
E360 Low Engine Oil Pressure
38 CONN 51 I-2 B
3 56 CONN 52 C-4 16
E361 High Engine Coolant Temperature
CONN 53 B-4 17
E362 Engine Overspeed
54 18 55
CONN 54 I-17 D
E390 Fuel Filter Restriction CONN 55 G-15 D
E539 High Intake Manifold Air Temperature CONN 56 H-4 17
The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.
Machine Harness Connector And Component Locations
 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
RELAY PANEL CONSOL LH
103-A48 RD-16 103-A47 RD-16 127-A140 OR-16 NEUTRAL START LIMIT SW JOYSTICK LH A-C15 SECONDARY SHUTDOWN SW
103-A48 RD-16 105-A94 RD-16 103-A19 RD-16 150-A1 RD-16 H-C3 1114799 H-C6 2277569 1552273 1702512
L 1 ATCH LAMP DELAY TIMER WK-C1 E-C29 K909-E89 BU-16 105-A94 RD-16 113-A50 OR-18 103-A48 RD-16 151-A75 GN-16 1552267 2305010 3 L
X977-E86 YL-18 5A 1636704 3E3364 1552269 K951-E88 GY-18 E-C34 BACKUP DIODE 3 113-A50 OR-18 118-A51 GY-14 154-A74 RD-16 A 1 +8V 235-A63 BK-18 1
2 5A RELAY 1 684-WK1 RD-18 1 684-E79 RD-18 1 7Y3952 1211022 118-A51 GY-14 123-A52 WH-18 105-A94 RD-16 320-A77 RD-18 B 2 GND 6
5A LAMP SW 2 2 646-E50 RD-18 K909-E89 BU-16 1 CONN 50 C 3 SIG L/R 4
10A F859-E60 GY-18 K951-E49 GY-18 K909-E90 BU-16 120-A110 YL-16 127-A140 OR-16 113-A49 OR-18 K848-A148 WH-18
3 BOOM DOWN BACKUP 2 2 123-A52 WH-18 129-A61 BU-16 113-A98 OR-18 K909-A10 BU-16 A-C1 H-C1 4 SIG F/R 5
1262941 15A E-C31 E-C30 F859-E92 GY-18 K951-E88 GY-18 E997-E107 BR-18 124-A46 GN-14 150-A1 RD-16 K943-A6 OR-18 2304009 2434510 5 F716-A73 WH-18 2
4 15A 3E3370 1552267 3 125-A72 RD-16 151-A75 GN-16 113-A50 OR-18 K944-A7 YL-18 127-A140 OR-16 1 6
P944-E87 GY-18 +B A A 105-E4 RD-16 F859-E92 GY-18 K909-E90 BU-16 127-A140 OR-16 154-A74 RD-16 118-A65 GY-14 K945-A11 GY-18 150-A1 RD-16 2 A-C19 A-C26 ATCH PEDAL LH
GND B B 200-E47 BK-16 4 K909-E91 BU-16 E-C32 BACKUP RESISTOR TR LH 129-A61 BU-16 199-A135 OR-18 118-A124 GY-14 K949-A8 OR-18 320-A77 RD-18 3 H-C7 H-C8 2397352 2472693 2475276
10A 1 103-GJ2 RD-18 KEY OFF C C 308-E62 YL-16 H733-E95 BU-18 1552269 1519360 150-A1 RD-16 251-A136 YL-18 K950-A9 YL-18 K848-A148 WH-18 4 2397352 2472693 M947-A22 OR-18 1 1 +12V
AM-C1 AM-C2 TIMER RELAY E-C3 10A 1 125-E106 RD-16 K909-E93 BU-16 K909-E93 BU-16 1 151-A75 GN-16 261-A137 GN-18 118-A51 GY-14 K951-A12 GY-18 K909-A10 BU-16 1 1 +B M948-A53 BR-18 2 2 GND
1552272 3E3376 1636703 1552272 10A 1 115-E9 RD-16 BOOM BACKUP RESISTOR K909-E94 BU-16 K945-E98 GY-18 2 5 2 2 GND M954-A56 BU-18 3 LEFT PEDAL
154-A74 RD-16 307-A23 OR-16 123-A52 WH-18 M942-A149 WH-18 L153 K945-A11 GY-18 6 3
1 110-AM9 RD-18 1 +B 1 110-E5 RD-18 10A 114-E7 RD-16 200-E43 BK-18 1453084 3 3 PWM OUT

101-WF1 RD-6
1 175-A106 RD-14 308-A60 YL-16 127-A140 OR-16 M943-A150 YL-18 K951-A12 GY-18 7 4 4 PWM (F-A)
2 200-AM10 BK-18 2 GND 2 200-E48 BK-18 5A 1 110-E5 RD-18 200-E46 BK-18 E-C35 BACKUP DIODE 4 179-A112 BU-16 308-A99 YL-16 129-A61 BU-16 M947-A2 OR-18 M942-A149 WH-18 8 4 4 SW-COM 5 5 NU
3 150-AM11 RD-18 3 OUT 3 150-E35 RD-18 15A 1 130-E16 RD-14 200-E44 BK-16 7Y3952 1211022 199-A135 OR-18 150-A1 RD-16 M948-A3 BR-18 M943-A150 YL-18 9 5 5 SW-1 6 6 NU
4 4 IN 4 5A 1 172-E69 RD-18 200-E70 BK-18 H733-E95 BU-18 1 307-A23 OR-16 151-A75 GN-16 M949-A4 PK-18 M947-A2 OR-18 10 6 6 SW-2
10A 1 105-E2 RD-16 200-E78 BK-18 M935-E96 BU-18 2 308-A101 YL-16 308-A101 YL-16 154-A74 RD-16 M950-A5 PU-18 M949-A4 PK-18 11 A-C14 PEDAL
CONN 9 E-C4 15A 1 131-E34 RD-14 200-E45 BK-16 199-A135 OR-18 H-C4 2397352 2475275
F874-AM8 PK-18 7Y3952 5A 103-E1 RD-18 308-E68 YL-18 E997-E107 BR-18 E-C33 BACKUP RESISTOR TR RH 320-A77 RD-18 308-A102 YL-16 M953-A152 BU-18 M950-A5 PU-18 12 7Y3967 1 M947-A57 OR-18
1 603-A80 PK-18 320-A77 RD-18 251-A136 YL-18 X976-A13 BU-16 1 +12V
K 308-AM7 YL-18 200-E48 BK-18 15A 1 175-E30 RD-14 308-E59 YL-18 K945-E98 GY-18 1552269 1519360 403-A59 GN-18 261-A137 GN-18 200-A78 BK-16 1 SW-3 M948-A117 BR-18 2 GND K
MAIN RELAY DIODE 1 200-E44 BK-16 30A 168-E27 RD-10 308-E56 YL-16 K909-E94 BU-16 607-A25 PK-16 A-C9 H-C2 1 M956-A118 GN-18
1 1 615-A62 YL-16 405-A44 GY-18 307-A23 OR-16 118-A124 GY-14 3 TRAVEL RIGHT
1211022 2 308-E57 YL-18 308-E62 YL-16 K948-E97 GY-18 K948-E97 GY-18 2 645-A55 RD-18 412-A35 BU-18 308-A60 YL-16 F716-A73 WH-18 2434510 2304009 H-C5 M957-A119 GY-18 4 TRAVEL LEFT
308-E82 YL-18 ATCH MSS RELAY 2 646-A54 RD-18 430-A34 BU-18 308-A99 YL-16 M947-A129 OR-18 151-A75 GN-16 1 7Y3967 5 NU
15A 1 118-E11 GY-14 1495050 487-A29 OR-18 320-A77 RD-18 M948-A128 BR-18 154-A74 RD-16 2 1 ATCH CONT HANDLE LH 6 NU
A623-E76 BU-18 10A 160-E25 PU-16 112-WG1 PU-6 AM-C4 ATCH BEACON RELAY K909-A24 BU-16 K943-A6 OR-18 3 2277617
1 1495050 K945-A11 GY-18 491-A30 PK-18 403-A59 GN-18 M954-A56 BU-18
CHASSIS LAMP DIODE 1 684-E79 RD-18 5A 1 123-E13 WH-18 1495051 E-C28 K948-A93 GY-18 495-A31 GN-18 405-A44 GY-18 M956-A118 GN-18 K944-A7 YL-18 4 HORN SW A-C20 A-C27 ATCH PEDAL RH
1211022 2 684-E41 RD-18 10A 1 129-E15 BU-16 101-WF1 RD-6 1 A346-AM4 BU-18 1495051 K951-A12 GY-18 496-A32 WH-18 412-A35 BU-18 M957-A119 GY-18 K949-A8 OR-18 5 ATCH AIR SUSPENSION 2220225 2397352 2472693 2475276
E-C5 5A 1 113-E6 OR-18 101-WE1 RD-6 2 M732-AM2 OR-18 1 308-C184 YL-16 X976-A13 BU-16 506-A33 PU-18 430-A34 BU-18 M960-A122 PU-18 K950-A9 YL-18 6 H-C9 H-C10 2405063 M947-A120 OR-18 1 1 +12V
7Y3952 10A 1 140-E52 BU-16 MAIN RELAY 3 307-AM5 OR-16 2 405-C100 GY-18 235-A68 BK-18 603-A80 PK-18 487-A29 OR-18 200-A141 BK-16 M948-A3 BR-18 7 2304011 2434505 M948-A121 BR-18 2 2 GND
10A 1 120-E12 YL-16 2130772 4 3 412-C169 BU-18 235-A43 BK-18 607-A25 PK-16 491-A30 PK-18 200-A126 BK-14 L98 M953-A152 BU-18 8 2 2 GND M960-A122 PU-18 3 3 RIGHT PEDAL
CHASSIS LAMP RELAY 10A 1 179-E32 BU-16 5 C904-AM6 GN-16 4 430-C162 BU-18 235-A131 BK-14 607-A142 PK-16 495-A31 GN-18 235-A43 BK-18 X976-A13 BU-16 9 1 1 + B 4 4 PWM (F-A)
1613128 15A 1 124-E14 GN-14 5 487-C71 OR-18 235-A132 BK-14 615-A62 YL-16 496-A32 WH-18 200-A78 BK-16 10 5 5 NU
FUSE INSTRUCTION E-C6 10A 1 196-E22 BU-16 491-C74 PK-18 CONN 31 645-A55 RD-18 506-A33 PU-18 235-A63 BK-18 11 6 6 NU
1495051 10A 1 176-E17 YL-16 200-E19 BK-16 495-C73 GN-18 C-C11 A-C11 646-A54 RD-18 603-A80 PK-18 235-A64 BK-18 12
1 10A 180-E33 GN-16 200-E51 BK-14 A-C24

112-WG1 PU-6
1 496-C72 WH-18 1636637 1532620 892-A37 BR-18 607-A25 PK-16 103-A19 RD-16 CONN 49
FUSE BASE FUSE 2 A623-E76 BU-18 5A 1 147-E103 PU-18 200-E63 BK-16 ATCH MSS RELAY 1 L31 514-C176 PU-16 235-C189 BK-14 893-A36 GN-18 607-A108 PK-16 105-A94 RD-16 1552272
3 160-E26 PU-18 15A 1 102-E105 BU-14 200-E64 BK-16 1 A580-A123 BR-14 2
1831000 5A 1412759 160-E25 PU-16 10A 149-E101 PU-16 200-E47 BK-16 1495050 AM-C3 L79 607-C54 PK-18 235-C190 BK-14 2 998-A89 BR-18 607-A142 PK-16 113-A98 OR-18 2 1 118-A124 GY-14
10A 1138490 4 1 892-C192 BR-18 F717-C107 YL-18 3 F718-A87 BU-18 A755-A81 PK-18 615-A62 YL-16 307-A23 OR-16 3 4
15A 1138491 5 607-E40 PK-16 10A 1 148-E84 WH-16 1495051 893-C194 GN-18 F718-C108 BU-18 F717-A86 YL-18 A756-A82 BU-18 645-A55 RD-18 308-A99 YL-16 A579-A125 OR-14 3 WIPER MOTOR
10A 1 1 A347-AM3 GN-18 4 200-A126 BK-14 1 + 2513482
30A 1243548 998-C102 BR-18 M954-C119 BU-18 5 M954-A56 BU-18 A757-A83 GY-18 646-A54 RD-18 508-A28 PU-18 2 1 5 4
10A 1 127-E71 OR-16 2 M733-AM1 PK-18 C468-C86 BU-18 M960-C127 PU-18 M960-A122 PU-18 A758-A84 BR-18 892-A37 BR-18 509-A20 WH-18 3 6 S +1
10A 1 113-GJ1 OR-16 3 308-AM7 YL-18 6 -
SPARE WIPER/WASHER 10A C506-C129 WH-16 M963-C130 BU-18 7 M963-A95 BU-18 A768-A92 BU-18 893-A36 GN-18 511-A27 BR-18
FUSE BASE GND RELAY PANEL 4 E554-C89 PK-18 M949-C131 PK-18 8 M949-A4 PK-18 C468-A38 BU-18 998-A89 BR-18 512-A26 GN-18 BACKUP SW TRAVEL LH 1636711 BACKUP SW BOOM 2341155
5A 15A CAB LAMP RELAY 1831000 VG01 2242862 5 F874-AM8 PK-18 F716-C110 WH-18 K909-C128 BU-16 K909-A153 BU-16 F716-A73 WH-18 A755-A81 PK-18 998-A89 BR-18
9
SPARE CHASSIS LAMP 1613128 E-C7
105-E4 RD-16 F717-C107 YL-18
F718-C108 BU-18
487-C71 OR-18
491-C74 PK-18
10 487-A29 OR-18
491-A30 PK-18
F717-A86 YL-18
F718-A87 BU-18
A756-A82 BU-18
A757-A83 GY-18
A537-A16 PK-16
A755-A81 PK-18
118-A124 GY-14
F716-A73 WH-18 CONSOL LH 607-A127 PK-16 CHASSIS LAMP 1
5A 10A 1495051 11 M947-A129 OR-18 200-A141 BK-16 1532523
115-E10 RD-18 105-E4 RD-16 G976-C166 BU-18 495-C73 GN-18 12 495-A31 GN-18 G976-A39 BU-18 A758-A84 BR-18 A756-A82 BU-18
SPARE SEAT HEATER 1 L30 H807-C77 YL-18 496-C72 WH-18 13 496-A32 WH-18 H807-A17 YL-18 A768-A92 BU-18 A757-A83 GY-18 L150
2 684-E41 RD-18 105-E3 RD-16 684-E79 RD-18 K909-C128 BU-16 14 L91 K848-A148 WH-18 C468-A38 BU-18 A758-A84 BR-18 M947-A22 OR-18
10A 5A 3 105-E2 RD-16 E997-E107 BR-18 M943-A150 YL-18 F716-A73 WH-18 A768-A92 BU-18 M947-A120 OR-18
SPARE CIGAR LIGHTER 4
5
115-E9
615-E73
RD-16
YL-16 102-E105 BU-14
X977-E86 YL-18
102-E105 BU-14
K943-C78 OR-18
K944-C79 YL-18
M953-C164 BU-18
430-C162 BU-18
15
16
M953-A88 BU-18
430-A34 BU-18 K909-A153 BU-16 F717-A86 YL-18 F717-A86 YL-18 M947-A57 OR-18 CONSOLE RH
10A 10A 103-E1 RD-18 130-E16 RD-14 AUTOLUB RELAY K946-C80 OR-18 412-C169 BU-18 17 412-A35 BU-18 K909-A24 BU-16 F718-A87 BU-18 F718-A87 BU-18 M948-A128 BR-18 A-C5 G-C1
113-E6 OR-18 131-E34 RD-14 1495050 E-C19 K947-C81 YL-18 308-C184 YL-16 18 308-A102 YL-16 K943-A6 OR-18 G976-A39 BU-18 H807-A17 YL-18 M948-A117 BR-18 2304009 2434510 G-C5 G-C6
J SPARE SW PANEL/RADIO K949-C82 OR-18 403-C140 GN-18 19 403-A59 GN-18 K944-A7 YL-18 H807-A17 YL-18 K847-A145 PU-18 ATCH SEAT HEATER J
118-E11 GY-14 147-E103 PU-18 1495051 K950-C83 YL-18 893-C194 GN-18 893-A36 GN-18 K945-A11 GY-18 K848-A148 WH-18 K909-A45 BU-16 M948-A53 BR-18 A755-A81 PK-18 1 2304011 2434505 2299093
15A 5A 120-E12 YL-16 151-E31 GN-16 1 801-E39 PK-18 L85 20 M948-A121 BR-18 A756-A82 BU-18 2 1 1
123-E13 WH-18 168-E27 RD-10 K952-C84 BR-18 892-C192 BR-18 21 892-A37 BR-18 K946-A14 OR-18 K847-A145 PU-18 K946-A14 OR-18 L95 M954-A56 BU-18 A757-A83 GY-18 JOYSTICK RH
SPARE AUTO LUB HORN RELAY 2 235-C189 BK-14 A755-C136 PK-18 22 A755-A81 PK-18 K947-A103 YL-18 L96 K909-A24 BU-16 K947-A103 YL-18 3 2 2 G-C7
1613128 124-E14 GN-14 172-E69 RD-18 3 140-E104 BU-16 235-C190 BK-14 A756-C137 BU-18 A756-A82 BU-18 K948-A93 GY-18 K948-A93 GY-18 M956-A118 GN-18 A758-A84 BR-18 4 2305010 2277569
15A 10A E-C8 125-E106 RD-16 310-E18 PU-18 4 23 M957-A119 GY-18 F717-A86 YL-18 5
1495051 127-E71 OR-16 317-E83 YL-18 251-C63 YL-18 A757-C132 GY-18 24 A757-A83 GY-18 K949-A8 OR-18 K909-A10 BU-16 K952-A18 BR-18 M960-A122 PU-18 F718-A87 BU-18 1 +8V
5 6

BR-18
261-C58 GN-18 A758-C133 BR-18 A758-A84 BR-18 K950-A9 YL-18 K909-A45 BU-16 L972-A85 BU-18

H807-E42 YL-18
P946-E28 BR-18
X976-E72 BU-18

BU-16
GY-18
GY-18
GY-18
BU-18
25 L99 2 GND

YL-16
RD-18
RD-18
BK-16
12V 7A CONVERTER 1 1 114-E8 RD-18 129-E15 BU-16 322-E67 GY-16 200-A141 BK-16 K847-A145 PU-18 7

RD-16
403-C140 GN-18 C468-C86 BU-18 26 C468-A38 BU-18 K951-A12 GY-18 M944-A146 BU-18 3 SIG L/R

200-E63 BK-16
10A 2 320-E66 RD-18 130-E16 RD-14 A755-C136 PK-18 514-C176 PU-16 27 514-A76 PU-16 K952-A18 BR-18 K909-A153 BU-16 M945-A147 BR-18 200-A126 BK-14 L972-A85 BU-18 8 4
3 114-E8 RD-18 131-E34 RD-14 235-A63 BK-18 M944-A146 BU-18 9 SIG F/R
12V 7A CONVERTER 2 114-E7 RD-16 892-E80 BR-18 A756-C137 BU-18 M950-C125 PU-18 28 M950-A5 PU-18 L919-A40 YL-18 K943-A6 OR-18 M947-A15 OR-18 M945-A147 BR-18 5
4 10

E997-E107
A757-C132 GY-18 L972-A85 BU-18 K944-A7 YL-18 M948-A97 BR-18

K909-E89
K945-E98
K948-E97
K951-E88
M935-E96
E554-C89 PK-18 29 E554-A107 PK-18 6

308-E62
646-E50
684-E79
200-E47
322-E67 GY-16 147-E103 PU-18 893-E81 GN-18 607-A127 PK-16 M947-A15 OR-18

105-E4
10A 5 A758-C133 BR-18 F716-C110 WH-18 30 F716-A73 WH-18 M942-A149 WH-18 K945-A11 GY-18 M953-A151 BU-18 11
101-CA1 RD-00 101-CC1 RD-00 200-CE1 BK-00 168-E27 RD-10 E997-E38 BR-18 A768-C142 BU-16 31 K847-A145 PU-18 K946-A14 OR-18 M962-A100 YL-18 A579-A125 OR-14 M962-A100 YL-18 12 G-C8 G-C12 1 +B
A/C CONDEN A/C 172-E69 RD-18 K924-E77 YL-16 E-C16 K848-C197 WH-18 M962-C40 YL-18 M962-A100 YL-18 M944-A146 BU-18 K947-A103 YL-18 M963-A95 BU-18 A580-A123 BR-14 2397352 2472693 2 GND
101-CP1 RD-00 10A 15A 175-E30 RD-14 P944-E87 GY-18 7Y3952 32 CONN 48 3 PWM OUT
176-E17 YL-16 K847-C155 PU-18 L972-C138 BU-18 33 L972-A85 BU-18 M945-A147 BR-18 K948-A93 GY-18 T902-A139 PK-18 A-C3 G-C2 1 4
L919-C139 YL-18 M947-C122 OR-18 34 M947-A21 OR-18 M947-A21 OR-18 K949-A8 OR-18 T901-A138 YL-18 2 SW-COM
POS NEG POS NEG BOOM LAMP 2 INSP LAMP HYD LOCK SOL RELAY 179-E32 BU-16 308-E56 YL-16 START RELAY DIODE 1 200-E64 BK-16 L972-C138 BU-18 M948-C120 BR-18 M948-A130 BR-18 M948-A130 BR-18 K950-A9 YL-18 200-A79 BK-18 2434510 2304009 5 SW-1
10A 10A 180-E33 GN-16 103-E1 RD-18 1211022 2 306-E54 GN-16 35 307-A23 OR-16 1 3 6 SW-2
1613128 E-C9 105-E3 RD-16 306-E23 GN-16 E-C27 M942-C171 WH-18 M956-C126 GN-18 36 M956-A118 GN-18 M949-A4 PK-18 K951-A12 GY-18 200-A133 BK-18 308-A99 YL-16 4
M943-C165 YL-18 M957-C152 GY-18 37 M957-A119 GY-18 A/C UNIT A-C16 M950-A5 PU-18 K952-A18 BR-18 2 5
CAB LAMP AUX CKT 1 1495051 196-E22 BU-16 113-E6 OR-18 1552269 2405036 2304009 200-A79 BK-18 3
BATTERY RH BATTERY LH 151-E21 GN-16 160-E25 PU-16 118-E11 GY-14 M944-C146 BU-18 607-C54 PK-18 38 607-A142 PK-16 M953-A88 BU-18 L919-A40 YL-18 H807-A17 YL-18 6 1

2
1
1535710 1535710 10A 10A 1 M945-C124 BR-18 G976-C166 BU-18 39 G976-A39 BU-18 B/R 1 124-A46 GN-14 M954-A56 BU-18 L972-A85 BU-18 607-A134 PK-16 4
2 200-E46 BK-18 149-E101 PU-16 120-E12 YL-16 E-C17 M947-C122 OR-18 40 B/W 2 200-A105 BK-14 M956-A118 GN-18 M942-A149 WH-18 607-A42 PK-16 K952-A18 BR-18 5 G-C9 SW-3
HORN AUX CKT 2 3 E997-E38 BR-18 148-E84 WH-16 123-E13 WH-18 BACKUP DIODE 1 7Y3952 M948-C120 BR-18 L919-C139 YL-18 L919-A40 YL-18 R 3 175-A106 RD-14 M957-A119 GY-18 M944-A146 BU-18 607-A25 PK-16 T901-A138 YL-18 6 7Y3967 1
10A 10A 4 E997-E107 BR-18 115-E9 RD-16 124-E14 GN-14 1211022 1 X976-E29 BU-18 41 R/G 4 E554-A107 PK-18 T902-A139 PK-18 7
K924-E77 YL-16 114-E7 RD-16 125-E106 RD-16 M949-C131 PK-18 C506-C129 WH-16 42 C506-A90 WH-16 M960-A122 PU-18 M943-A150 YL-18 607-A142 PK-16 998-A89 BR-18 1
5 2 M950-C125 PU-18 A768-C142 BU-16 43 A768-A92 BU-18 P 5 607-A108 PK-16 M962-A100 YL-18 M945-A147 BR-18 607-A108 PK-16 8 ATCH CONT HANDLE RH
TIMER RLAY ATT SOL 110-E5 RD-18 127-E71 OR-16 START RELAY M953-C164 BU-18 44 B 6 200-A109 BK-14 M963-A95 BU-18 607-A58 PK-16 A768-A92 BU-18 9 2277616
CONN 54 5A 5A 129-E15 BU-16 1251302 R/W 7 514-A76 PU-16 M948-A97 BR-18 10
110-E5 RD-18 150-E35 RD-18 E-C18 M954-C119 BU-18 998-C102 BR-18 45 998-A89 BR-18 T901-A138 YL-18 M947-A21 OR-18 607-A127 PK-16 M953-A151 BU-18 1
M956-C126 GN-18 405-C100 GY-18 46 405-A44 GY-18 O/G 8 C506-A90 WH-16 T902-A139 PK-18 M947-A129 OR-18 11
ABL CONT 1 ENG CONT 114-E7 RD-16 151-E20 GN-16 7Y3952 R/L 125-A72 RD-16 235-A64 BK-18 12 G-C10

E997-E107 BR-18
9 X976-A13 BU-16 M947-A15 OR-18 M-C2

X977-E86 YL-18

BU-16
GY-18
GY-18
M957-C152 GY-18 K952-C84 BR-18 47 K952-A18 BR-18 ONE TOUCH

308-E62 YL-16
684-E79 RD-18

200-E63 BK-16
200-E47 BK-16
RD-18
115-E9 RD-16 154-E24 RD-16 BACKUP DIODE 2 7Y3967

105-E4 RD-16

RD-8

304-WC1 WH-8
15A 15A NEUTRAL START RELAY M960-C127 PU-18 K950-C83 YL-18 48 K950-A9 YL-18 10 200-A79 BK-18 M947-A2 OR-18 103-A47 RD-16 CONN 47 7Y3952
1613128 148-E84 WH-16 175-E30 RD-14 1211022 1 X976-E72 BU-18 11 200-A66 BK-18 113-A49 OR-18 LOW IDLE SW 1 GND
101-CR1 RD-00 PRODUCT LINK BOOM LAMP 2 E-C10 X977-E86 YL-18 M962-C40 YL-18 K949-C82 OR-18 49 K949-A8 OR-18 2220225 2
2 M963-C130 BU-18 K947-C81 YL-18 50 K947-A103 YL-18 12 200-A133 BK-18 M948-A130 BR-18 118-A65 GY-14 CONN 51 +B
5A 10A 1495051 160-E25 PU-16 179-E32 BU-16 200-A126 BK-14 M948-A3 BR-18 123-A52 WH-18 A-C2 G-C3 IND UNIT

K909-E89
K945-E98
K948-E97
K951-E88
K946-C80 OR-18 51 K946-A14 OR-18

646-E50
154-E24 RD-16 196-E22 BU-16 2312295 2434509 G-C11 M-C1

109- 1
1 WASHER MOTOR A-C29 K944-C79 YL-18 52 K944-A7 YL-18 200-A69 BK-14 M948-A128 BR-18 129-A61 BU-16 1709324
I KEY SW SPARE 2 200-E43 BK-18 150-E35 RD-18 307-E55 OR-16 7T8890 7T5957 K943-C78 OR-18 K943-A6 OR-18 200-A78 BK-16 M948-A97 BR-18 199-A135 OR-18 105-A94 RD-16 1 1027964 1211168 I
10A 5A 3 307-E55 OR-16 154-E24 RD-16 320-E66 RD-18 53 607-A42 PK-16 2 1 M-C3
607-E40 PK-16 MOTOR 12 200-A144 BK-18 H807-C77 YL-18 54 H807-A17 YL-18 200-A141 BK-16 M949-A4 PK-18 251-A136 YL-18 A537-A16 PK-16 1552273
4 506-A33 PU-18 235-A43 BK-18 M950-A5 PU-18 261-A137 GN-18 3 2
ABL CONT 2 SPARE 5 307-E55 OR-16 615-E73 YL-16 C-C16 A-C22 235-A68 BK-18 M953-A88 BU-18 308-A60 YL-16 K909-A45 BU-16 4 3 1 BK COM

L151
15A 5A 308-E59 YL-18 2434510 2304009 607-A108 PK-16 M953-A88 BU-18 403-A59 GN-18 K946-A14 OR-18 5 4 2 PK S1
308-E68 YL-18 235-E65 BK-18 261-C58 GN-18 1 GN-18 261-A137 120-A110 YL-16 M953-A151 BU-18 405-A44 GY-18 K947-A103 YL-18 6 5 3 BU S2
DOME LAMP/MEMORY SPARE 310-E18 PU-18 251-C63 YL-18 YL-18 251-A136 179-A112 BU-16 M953-A152 BU-18 412-A35 BU-18 K948-A93 GY-18 7 6 4 GN S3
101-CF1 RD-00 101-CG1 RD-00 5A 10A 317-E83 YL-18 2 M963-A95 BU-18 8 7 5 BR S4
320-E66 RD-18 L197 K848-C197 WH-18 3 WH-18K848-A148 200-A111 BK-16 M954-A56 BU-18 430-A34 BU-18
ETHER RELAY M942-C171 WH-18 4 WH-18M942-A149 200-A113 BK-16 M956-A118 GN-18 487-A29 OR-18 CONN 46 8 6
A/C BLOWER SPARE 1613128 322-E67 GY-16 M943-C165 YL-18 5 YL-18M943-A150 M957-A119 GY-18 491-A30 PK-18 9 THROTTLE POS SW
15A 10A E-C11 607-E40 PK-16 124-A46 GN-14 M960-A122 PU-18 495-A31 GN-18 L145 10 1060107
1495051 615-E73 YL-16 A-C29 K847-C155 PU-18 6 PU-18K847-A145 11
POS NEG POS NEG 7T5957 M944-C146 BU-18 7 BU-18M944-A146 125-A72 RD-16 M962-A100 YL-18 645-A55
496-A32 RD-18
WH-18
REFUELING PUMP SPARE 1 317-E83 YL-18 M945-C124 BR-18 BR-18M945-A147 175-A106 RD-14 M963-A95 BU-18 506-A33
646-A54 PU-18
RD-18 12
30A 10A 2 200-E78 BK-18 1 MOTOR WASHER MOTOR 8 13
308-E82 YL-18 2 7T8890 9 514-A76 PU-16 T901-A138 YL-18 603-A80
892-A37 PK-18
BR-18
ATCH BATTERY RH ATCH BATTERY LH 3 10 C506-A90 WH-16 T902-A139 PK-18 893-A36
615-A62 GN-18
YL-16 14 R

L148
1535710 1535710 4 308-E59 YL-18 684-E79 RD-18 T901-C67 YL-18 11 T901-A138 YL-18 E554-A107 PK-18 X976-A13 BU-16 C468-A38 BU-18 A-C4 G-C4 15
5 310-E18 PU-18 892-E80 BR-18 T902-C134 PK-18 T902-A139 PK-18 200-A109 BK-14 200-A66 BK-18 G976-A39 BU-18 2434509 2312295 16 C OFF
893-E81 GN-18 12 113-A98 OR-18 1 17
E997-E38 BR-18 CONN 32 A-C23 ATT 12V 7A CONVERTER 1 A-C17 200-A105 BK-14 200-A133 BK-18 L919-A40 YL-18 200-A133 BK-18 S ON
200-A126 BK-14 200-A69 BK-14 2 18 B ST
E997-E107 BR-18 2434508 2341004 2305010 L92 200-A69 BK-14 L146 200-A66 BK-18 509-A20 WH-18 3 19
ALTERNATOR K924-E77 YL-16 1 +12 V SWITCHED OUT 1 200-A141 BK-16 235-A68 BK-18 512-A26 GN-18 4 20 KEY SWITCH
1779953 E-C14 P944-E87 GY-18 L196 200-A111 BK-16 2 135-A67 BU-16 120-A110 YL-16 L147 607-A134 PK-16 21
BOOM LAMP RELAY 1 200-A141 BK-16 +12 V MEMORY OUT 2 200-A79 BK-18 5 9G7641
109-C91 RD-4 7T5957 1613128 X977-E86 YL-18 200-A109 BK-14 3 GROUND 3 210-A70 BK-16 200-A78 BK-16 103-A19 RD-16 6 ANTENNA
B 1 200-E19 BK-16 E-C12 200-E19 BK-16 200-A133 BK-18 4 GROUND 4 200-A111 BK-16 120-A114 YL-16 235-A43 BK-18 508-A28 PU-18 7
R 403-C88 GN-16 2 196-E22 BU-16 1495051 200-A113 BK-16 5 +24 V SWITCHED IN 5 120-A104 YL-16 120-A104 YL-16 235-A68 BK-18 511-A27 BR-18 8

BK-18
BK-14
BK-14
BK-16
BK-14
BK-18
BK-16
BK-16
1 200-E43 BK-18 6 +24 V BATTERY IN 6 120-A114 YL-16 179-A112 BU-16

109-WH1 RD-6
101-WJ1 RD-6
E

BK-16
BK-18

BK-18
BK-14
200-C87 BK-4 200-E78 BK-18 200-A66 BK-18 L149 508-A28 PU-18 CONN 45 6C3431
2 200-A105 BK-14 509-A20 WH-18 M-C4 M-C5

125-E106 RD-16

BU-16
GY-18
GY-18
GY-18
BU-18

BU-14

PU-18

BR-18
YL-16
GY-18
BU-16

M935-E96 BU-18
P946-E28 BR-18
118-E11 GY-14
120-E12 YL-16
123-E13 WH-18
124-E14 GN-14
127-E71 OR-16
129-E15 BU-16
150-E35 RD-18
151-E20 GN-16
154-E24 RD-16
175-E30 RD-14
179-E32 BU-16
OR-16
YL-16
RD-18
PK-16
YL-16
200-E51 BK-14

RD-18

RD-14
RD-14
GN-16
RD-18
PU-18
YL-18
GY-16

BR-18
GN-18

OR-16
PK-18
3 149-E99 PU-18 200-E46 BK-18 179-A115 BU-16

103-E1 RD-18
105-E3 RD-16
113-E6 OR-18
E-C15 149-E101 PU-16 200-E70 BK-18 200-A78 BK-16 A-C25 ATT 12V 7A CONVERTER 2 A-C18 179-A116 BU-16 511-A27 BR-18 M-C6 1552269 3E3364
4 200-A79 BK-18 512-A26 GN-18 1

A579-A125 OR-14
A580-A123 BR-14
607-A127 PK-16
C569-A91 YL-16

A537-A16 PK-16

199-A135 OR-18
251-A136 YL-18
261-A137 GN-18

C468-A38 BU-18
G976-A39 BU-18
L919-A40 YL-18
C-C25 9W1951

200-A144
200-A105
200-A109
200-A111
200-A126
200-A133
200-A141
200-A113
A/C CLUTCH SOL 5 616-E102 BU-16 235-E65 BK-18 2434508 2341004 2305010 200-A111 BK-16 1532541

135-A67 BU-16
210-A70 BK-16
229-A96 BK-16
508-A28 PU-18
509-A20 WH-18
511-A27 BR-18
512-A26 GN-18
103-A47 RD-16
113-A49 OR-18
118-A65 GY-14
123-A52 WH-18
129-A61 BU-16

308-A60 YL-16
403-A59 GN-18
405-A44 GY-18
412-A35 BU-18
430-A34 BU-18
487-A29 OR-18
491-A30 PK-18
495-A31 GN-18
496-A32 WH-18
506-A33 PU-18
603-A80 PK-18
607-A58 PK-16

892-A37 BR-18
615-A62 YL-16
645-A55 RD-18
646-A54 RD-18
893-A36 GN-18

200-A69 BK-14
200-A66 BK-18
235-A68 BK-18
200-A78
200-A79

200-A66
200-A69
2597243 2304011 308-E68 YL-18 616-E74 BU-18 151-E21 GN-16 200-A69 BK-14 1 200-A113 BK-16 A537-A16 PK-16 2
A +12 V SWITCHED OUT 1 A-C4 AJ-C1 ANTENNA ACC 1

K909-E89
K945-E98
K948-E97
K951-E88
X976-E72

K924-E77
102-E105

147-E103

E997-E38
P944-E87
140-E104
200-A126 BK-14 2 3

307-E55
308-E56
320-E66
607-E40
615-E73

646-E50

130-E16
131-E34
151-E31
172-E69
310-E18
317-E83
322-E67

892-E80
893-E81

709-E37
801-E39
1 E554-C89 PK-18 B 235-E65 BK-18 2 +12 V MEMORY OUT 2 C569-A91 YL-16 2434509 2312295 1 GND 2 1
2 200-C92 BK-18 C 151-E20 GN-16 3 GROUND 3 229-A96 BK-16 135-A67 BU-16 1 113-AJ1 OR-18 5 6 SPKR LH(-) 3 2
CONN 8 D 893-E81 GN-18 151-E31 GN-16 4 GROUND 4 200-A113 BK-16 C569-A91 YL-16 2 200-AJ3 BK-18 4 AUX-SPKR(-) 4
E 892-E80 BR-18 BOOM LAMP RELAY 2 5 +24 V SWITCHED IN 5 179-A115 BU-16 210-A70 BK-16 3 509-AJ4 WH-18 8 9 SPKR RH(-) 5 ATCH EXCITER COIL
H F 1613128 6 +24 V BATTERY IN 6 179-A116 BU-16 229-A96 BK-16 4 512-AJ5 GN-18 2 1 ILLUM 6 2065208 H
G E-C13 BREAKER 2 1 7 BACKUP 7
1495051 1712210 5 3 11 12 3 SPKR LH(+) 8 M-C7
ENG OIL LEVEL SW K-C7 H 6 103-AJ6 RD-16 10
2130677 J 1 616-E74 BU-18 GND PLATFORM 7 508-AJ7 PU-18 AUX-SPKR(+) 9 7Y3966
1552269 2 109-WH1 RD-6 L105 L105 BACKUP SW BACKUP EPR BACKUP GOV SW SPKR RH(+) 10 1
C468-K24 BU-18 80A 8 511-AJ8 BR-18 TRA RH 1636711
1 3 ATCH MSS CONT VALVE SW
2 235-K25 BK-18 4 307-AL17 OR-16 307-AL14 OR-16 2075262 CONN 56 L171 1636711 M-C8
5 633-E85 BU-16 101-WJ1 RD-6 307-AL16 OR-16 307-AL15 OR-16 AL-C1 GN-C2 GATEWAY WORLDVIEW MODULE 1636710 7Y3967
L184 A346-AL5 BU-18 1506766 1607690 2399954 L144 1
A347-AL13 GN-18 172-AL1 RD-18 1 +B 1 CONSOLE RH

168-E27 RD-10
E-C20 M732-AL28 OR-18 2

101-WJ1 RD-6
101-WE1 RD-6
109-WH1 RD-6
109-WA1 RD-8
304-WC1 WH-8
2 ATCH RADIO AM/FM(JPN)

645-E100 RD-18

RD-16
GY-18
GY-18
BU-18
BU-16
GY-18

BU-18
PK-18
OR-18
GN-18

GN-16
175-E30 RD-14

YL-16
OR-16
RD-18
RD-18
PK-16
RD-16
YL-16
GY-14

124-E14 GN-14
120-E12 YL-16
179-E32 BU-16
129-E15 BU-16

307-E55 OR-16

123-E13 WH-18
200-E51 BK-14

GN-16
RD-18
K-C6 7Y3967 M733-AL31 PK-18 235-AL4 BK-18 GND

OR-16
3 3

RD-16

RD-18

113-E6 OR-18
E-C36 2510537

BR-18
PU-18

BU-16

YL-16

102-E105 BU-14
YL-18

BR-18
GY-18
BU-18

BU-16
SPEED SENSOR

RD-14

YL-18

172-E69 RD-18
801-E39 PK-18
GN-18
BR-18

GY-16
RD-14
PU-18

GN-16
OR-16
BU-16
1552269 DISCONNECT SW 196-E22 BU-16 1 2304011 4 4

A579-A125 OR-14

A580-A123 BR-14
6V2455

A537-A16 PK-16
199-A135 OR-18

G976-A39 BU-18

C569-A91 YL-16

YL-18

BU-18
1 788-K22 YL-18 7N0718 308-E68 YL-18 308-AL12 YL-16 A346-AL5 BU-18 5 DRVR #2 OUT 5

200-A66 BK-18
892-A37 BR-18
893-A36 GN-18
103-A47 RD-16
113-A49 OR-18
430-A34 BU-18
487-A29 OR-18
506-A33 PU-18
118-A65 GY-14
129-A61 BU-16

603-A80 PK-18

135-A67 BU-16
210-A70 BK-16
229-A96 BK-16

646-A54 RD-18
123-A52 WH-18
BK-18
RD-18
PK-16
GN-18
GY-18
BU-18
PK-18
GN-18
WH-18
YL-16
L183

251-A136 YL-18
261-A137 GN-18

BK-14
YL-16
PU-18
WH-18
BR-18
GN-18
M953-K23 BU-18 7N0719 892-E80 BR-18 E-C21 E-C37 403-AL20 GN-18

1
2
2 6 6

125-E106
K948-E97
K951-E88
X976-E72
K909-E89
K945-E98

A346-AM4
M733-AM1
M732-AM2
A347-AM3

C904-AM6
615-E73
127-E71
320-E66
150-E35
607-E40
154-E24
308-E56
118-E11

151-E20
646-E50
893-E81 GN-18 7Y3967 2434505 172-AL2 RD-18 172-AL1 RD-18 T901-AL6 YL-18 EXCITER COIL

307-AM5
105-E3

103-E1
7 7

E997-E38
147-E103

140-E104

K924-E77
H807-E42

P946-E28
P944-E87
M935-E96

616-E102
130-E16

317-E83
893-E81
892-E80

322-E67
131-E34
310-E18

151-E31
709-E37
633-E85
200-E19 BK-16 1 308-AL8 YL-16 T902-AL29 PK-18 53 EXCITER COIL 8 CAT DATA LINK +

L919-A40

C468-A38
200-CE1 BK-00 235-E65 BK-18 C-C17 C-C26 AL-C4 308-AL9 YL-16 8 9 CAT DATA LINK -

235-A68
645-A55
607-A58
403-A59
405-A44
412-A35
491-A30
495-A31
496-A32
308-A60

200-A69
615-A62
508-A28
509-A20
511-A27
512-A26
STARTER MOTOR 2305010 2434508 2434508 308-AL10 YL-16 308-AL8 YL-16 9 DRVR #1 SPLY 10
272-7123 200-CH1 BK-00 172-C65 RD-18 1 1 172-AL3 RD-18 403-AL19 GN-18 10 11
304-K20 WH-8 308-C183 YL-16 2 2 308-AL11 YL-16 892-AL25 BR-18 A347-AL13 GN-18 11 DRVR #1 OUT 12
G S E-C23 E-C24 E-C25 E-C26 AM-C5 403-C195 GN-18 3 CONN 30 3 403-AL21 GN-18 12 13 RS-232 PORT #1-TXD A-C28
E-C22 892-C191 BR-18 892-AL27 BR-18 893-AL22 GN-18 13 A-C7
2304009 2434510 2312295 2304009 2434510 2305010 4 4 14 1211168 1027964
MTR BAT 101-K21 RD-4 893-C193 GN-18 5 5 893-AL24 GN-18 235-AL4 BK-18 14 15 A-C8

10
11
12

10
11
12

10
11
12

10
11
12
CONN 10 A-C10 CONN 16 CONN 17 CONN 19 CONN 20 235-C188 BK-18 235-AL46 BK-18 235-AL18 BK-18 1288951

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9
CONN 18 15 16

1
2
3
4
5
6
101-CR1 RD-00 CONN 55 BLOCK AS 6 6 CONN 42 CONN 43 CONN 44
CAB

10
11
12
13
14
15
16
17
18
19
20
21

10
14

11
12
13
15
16
17
18
19
20
21
2434510 235-AL44 BK-18

1
2
3
4
5
6
7
8
9

1
2
3
4
5

6
7
8
9

1
2
3
4
5
6
7
MOTOR A-C12 A-C13 7Y5499 C-C15 C-C19 AL-C6 16 17
101-CA1 RD-00 2304009 2434509 2434510 2304009 2434508 892-AL26 BR-18 17 18 F-C8 F-C10
893-AL23 GN-18 307-AL14 OR-16 18 DRVR #2 SPLY 19 F-C9 1114815

E997-C150 BR-18

P946-C157 BR-18
1027964

YL-16
BU-16

200-A143 BK-14

GY-18
GY-18
BU-16
BU-16
GY-18

130-C154 RD-14
147-C181 PU-18
893-C117 GN-18
892-C115 BR-18

131-C153 RD-14
310-C158 PU-18
K924-C56 YL-18
317-C106 YL-18

801-C147 PK-18

P944-C59 GY-18
M935-C60 BU-18
151-C148 GN-16
175-A106 RD-14

127-A140 OR-16

308-A101 YL-16

OR-18

H807-C57 YL-18

172-C65 RD-18
RD-18
1211168

235-A71 BK-14
105-A94 RD-16
615-A62 YL-16
320-A77 RD-18

GN-14

BU-16
RD-18
OR-16
113-A50 OR-18
123-A52 WH-18

GN-16
RD-16

140-C64 BU-16
322-C55 GY-18

102-C93 BU-14

709-C61 OR-16
616-C62 BU-16
103-A48 RD-16
607-A25 PK-16
154-A74 RD-16
118-A51 GY-14

PK-18
235-AL32 BK-18 235-AL18 BK-18 19 GND 20 +

150-A1 RD-16

168-C52 RD-10
101-CF1 RD-00 20 -

101-C97 RD-4
109-C91 RD-4
304-C96 WH-8
21

PK-18
OR-18

GN-16
GN-18
BU-18
OR-16
C-C33 C-C34 AL-C10 AL-C3 AL-C2 21 22 RS-232 PORT #1-RXD ATCH CAB LAMP(LH)
STRAP PC 2304011 2434505 2434505 1552269 1552269 22 23 RS-232 PORT #1-DTR SPEAKER(R) F-C13 R-C1 R-C3 1673441

120-A110
179-A112

K948-A93
K951-A12
X976-A13
K909-A24
K945-A11
199-A135

646-A54
124-A46

129-A61
645-A55
307-A23

151-A75
125-A72
603-A80
1288886 T901-C67 YL-18 1 1 T901-AL7 YL-18 1 1 T901-AL6 YL-18 23 24 2148889 7Y3967 7Y3966 7Y3967
T902-C134 PK-18 2 CONN 29 2 T902-AL30 PK-18 2 2 T902-AL29 PK-18 308-AL10 YL-16 24 KEY ON 25 1 1 RD-16

M733-AL31
M732-AL28

C904-AL45
A347-AL13
A346-AL5
307-AL17
G GND CHASSIS 1 25 26 G
FERRITE COIL AS 403-AL19 GN-18 26 ALT R TERM. 27 F-C14 R-C2 R-C4
AL-C5 AL-C9 GN-C1 2223870 27 28 + 7Y3966 7Y3967 7Y3966
2305010 2434508 2434508 28 29 - 1 1 WH-16
172-AL2 RD-18 1 1 29 30 RS-232 PORT #1-CDC ATCH CAB LAMP(RH)
308-AL12 YL-16 2 2 30 31 RS-232 PORT #1-GND SPEAKER(L) F-C15 R-C1 R-C3 1673441
403-AL20 GN-18 3 3 307-AL15 OR-16 31 CRANK POSN IP 32 2148889 7Y3967 7Y3966 7Y3967
892-AL26 BR-18 4 CONN 28 4 32 33 1 1 RD-16
893-AL23 GN-18 5 5 33 34 J1939 LOW
235-AL32 BK-18 6 6 34 35 F-C19 R-C2 R-C4

10
11
12
1
2
3
4
5
6
7
8
9
ENG CONT K-C1 AL-C7 35 36 7Y3966 7Y3967 7Y3966
1723353 1607689 2304009 36 37 1 1 WH-16
1 GL-C2 GL-C1 GN-C5 37 38
ANALOG SENSOR POWER 2 L88 8T8732 2434508 2305010 38 39 F-C12
ANALOG SENSOR RETURN 3 L152 B 1 1 39 40 2304011 WINDOW LIMIT SW
THROTTLE POWER 4 C 2 2 40 41 DOME LAMP 1892054
THROTTLE RETURN 998-K1 BR-18 A CONN 27 34 F-C31 6C9121

1
2
5 3 41 42
6 4 893-AL22 GN-18 42 CDL(+) 43 2434505
7 5 5 43 44 CONN 41
CAT DATA LINK (+) 8 893-K2 GN-18 6 6 44 45
CAT DATA LINK (-) 892-K3 BR-18 892-AL25 BR-18 CDL(-) AJ-C3

1
2
9 45 46
10 46 47 2434505
11 235-AL44 BK-18 47 GND 48

P946-C157 BR-18

E997-C150 BR-18
MONITOR

147-C181 PU-18

310-C158 PU-18
317-C106 YL-18

892-C115 BR-18
893-C117 GN-18
H807-C57 YL-18
K924-C56 YL-18
M935-C60 BU-18
P944-C59 GY-18
130-C154 RD-14
131-C153 RD-14
151-C148 GN-16
801-C147 PK-18

120-A110 YL-16

127-A140 OR-16

175-A106 RD-14
179-A112 BU-16
199-A135 OR-18
308-A101 YL-16

K909-A24 BU-16
K948-A93 GY-18
K945-A11 GY-18
K951-A12 GY-18
X976-A13 BU-16
BK-14
BK-14

BK-14

BK-14

BK-14
102-C93 BU-14
140-C64 BU-16
168-C52 RD-10
172-C65 RD-18

103-A48 RD-16
322-C55 GY-18
616-C62 BU-16
709-C61 OR-16

105-A94 RD-16
113-A50 OR-18
118-A51 GY-14
123-A52 WH-18
124-A46 GN-14
125-A72 RD-16
129-A61 BU-16
151-A75 GN-16
154-A74 RD-16

307-A23 OR-16
320-A77 RD-18
603-A80 PK-18
607-A25 PK-16
615-A62 YL-16
645-A55 RD-18
646-A54 RD-18

BK-18
BK-18
BK-14

BK-18
BK-18
C-C8 C-C23 48 F-C22

101-C97 RD-4
109-C91 RD-4

304-C96 WH-8
12 START AID SOL 49

150-A1 RD-16
13 2391134 3E3364 1552269 49 50 J1939 HIGH 2397356 2218941
310-C158 PU-18 CONN 26 1
14 1 1 50 51 FUEL LEVEL

113-AJ1 OR-18
139-AJ9 OR-18
15 2 2 200-C159 BK-18 GK-C1 GN-C3 51 52 UNSWITCHED POWER 2 COOLANT TEMP

235-A131
235-A132

200-A143

235-A131

235-A132

A513-AJ10 RD-18
235-A68
235-A43
235-A71

235-A43
235-A68
16 109-C91 RD-4 2434508 2305010 M732-AL28 OR-18 52 DRVR #2 RTN 53 3

A513-AJ10 RD-18
HYD OIL TEMP

592-AJ11 BU-18
GN-14
YL-16
OR-18
BU-16
BU-16
RD-18
OR-16
BK-16
OR-18
WH-18
BK-14

592-AJ11 BU-18
200-AJ2 BK-18

200-AJ2 BK-18
509-AJ4 WH-18
508-AJ7 PU-18

512-AJ5 GN-18
511-AJ8 BR-18

200-AJ3 BK-18
103-AJ6 RD-16
17 403-C88 GN-16 1 54 54 ALTERNATOR R-TERM 4 ALT R-TERM.
18 C468-C86 BU-18 2 55 55 GROUND-CAB 2 5 NU
19 E554-C89 PK-18 3 56 56 6 NU
ETHER RELAY 20 317-K19 YL-18 C-C12 4 57 57 7 NU

124-AL33
120-AL34
199-AL35
179-AL36
129-AL37
645-AL39
307-AL16
200-AL40
113-AL41
123-AL42
200-AL43
21 200-C87 BK-4 7Y3966 5 M733-AL31 PK-18 58 DRVR #1 RTN 58 8 ENG OIL PRESS.
THROTTLE BACKUP (ACCEL) 22 F717-K5 YL-18 200-C92 BK-18 1 200-C160 BK-18 6 59 59 9 ENG OIL LEVEL
THROTTLE BACKUP (DECEL) 23 F718-K6 BU-18 AIR CLEANER SW C-C13 60 LED RED 60 10 COOLANT LEVEL
F 24 K-C5 C-C28 1626208 7Y3967 1 61 61 11 HYD OIL LEVEL F
25 1275486 1275485 1 430-C162 BU-18 GK-C3 2 62 LED GREEN 62 RS-232 PORT #3-TXD 12 AIH CONT STATUS
26 304-K20 WH-8 1 304-C96 WH-8 GND CHASSIS 2 1552252 3 63 63 RS-232 PORT #3-RXD F-C23
AL-C8 AJ-C4 AJ-C2

10
11
12
308-AL9 YL-16 DRVR #2 ENABLE RS-232 PORT #3-GND 2304009

1
2
3
4
5
6
7
8
9
27 CONN 7 2434510 4 64 64 2312295 2305010

10
11
12
LOW OIL PRESSURE OUTPUT 28 405-K7 GY-18 ATCH WATER SEPARATOR 65 65 GROUND 1 + BATTERY

1
2
3
4
5
6
7
8
9
5
K-C4 C-C29 C-C21 C-C20 AJ-C5

GND

1
2
3
4
5
6
7
8

1
2
3
4
5
6
3

BATT +
29 66 66

KEY SW ON
ACC

ALT R-TERM
RS-232 TXD
RXD
GND
DTR
DCD
LEVEL SENSOR 1719091 3E3376 L97 6
30 L41 1275483 1275484 1552272 GK-C2 GN-C4 67 67 2434509 4 NU
+B

+12 V MEMORY OUT

+12 V SWITCHED OUT
12V GROUND
24V GROUND
+24 V BATTERY IN
+24 V SWITCHED IN
31 101-K21 RD-4 1 101-C97 RD-4 1 1 147-C163 PU-18 2305010 2434508 68 68 7 CDL +

RS-232
RX-232
RX-232
RX-232
32 CONN 6 GND 2 2 235-C121 BK-18 69 69 8 CDL -
33 SIGNAL 3 3 G976-C166 BU-18 CONN 25 70 70 KEY SWITCH ON 5 CAN3 +
34 4 4 F-C7 ACTION ALARM 6 CAN3 -
35 K-C3 C-C2 1552269 1321829 2 GND
36 2434508 2305010 UNDER WINDOW 1 9
L77 PROD LINK 2ND GENERATION RADIO LIMIT SW J1939 SHIELD
37 C468-K24 BU-18 1 C468-C86 BU-18 2429230 2 10 J1939 +
38 235-K25 BK-18 2 235-C90 BK-18 235-C123 BK-18 235-C167 BK-18 1892054 11 J1939 -
39 3 L89 12 ALARM
40 788-K22 YL-18 4 788-C98 YL-18 COOLANT LEVEL SW C-C14 F-C5 SERVICE METER
41 M953-K23 BU-18 5 M953-C99 BU-18 2459206 1552269 1532602 1978832
42 405-K7 GY-18 405-K7 GY-18 6 405-C100 GY-18 1 412-C169 BU-18 C-C10 RESISTOR 1 1 +B F-C3
43 102-K9 BU-14 2 235-C123 BK-18 3E3370 1743016 F-C20 9G1906
44 102-K8 BU-14 CONN 5 251-C141 YL-18 A RADIO CONVERTER 1532602 1 CIGAR LIGHTER
45 102-K10 BU-14 K-C2 C-C22 261-C156 GN-18 B 2341004 1 GROUND 2382318
102-K17 BU-14 2434510 2304009

1
46 C F-C21
47 L39 102-K17 BU-14 102-K17 BU-14 1 102-C93 BU-14 L78 1532602 F-C6
+B 48 102-K8 BU-14 229-K12 BK-14 229-K18 BK-14 2 229-C101 BK-14 200-C160 BK-18 1 SIGNAL 1532602
49 229-K13 BK-14 998-K1 BR-18 3 998-C102 BR-18 VALVE CONT C-C31
50 229-K14 BK-14 892-K3 BR-18 4 892-C103 BR-18 200-C159 BK-18 1607689 C-C1 1573200 1607690 F-C32 RESISTOR
51 229-K18 BK-14 893-K2 GN-18 5 893-C104 GN-18 F889-C109 WH-18 1 THROTTLE POSITION (TO ADEM) +B 1 130-C1 RD-14 WIPER CONT 3E3370 1743016
+B 52 102-K9 BU-14 6 200-C177 BK-16 M962-C40 YL-18 2 RH JOYSTICK (X-AXIS) GND 2 235-C2 BK-14 1887681 A
+B 53 102-K10 BU-14 308-K16 YL-16 L40 317-K19 YL-18 7 317-C106 YL-18 M957-C152 GY-18 3 TRAVEL LEFT PEDAL STICK (RETRACT) 3 K928-C11 GN-18 +24V 11 B
54 317-K19 YL-18 F717-K5 YL-18 8 F717-C107 YL-18 M954-C119 BU-18 4 LEFT ATT PEDAL ATT RETRACT 4 P958-C12 PK-18 BRAKE WIP 10 C
55 892-K3 BR-18 F718-K6 BU-18 9 F718-C108 BU-18 403-C196 GN-18 5 ALTERMATOR (R TERM) UNUSED 5 MOT WIPER 9 SWITCH PANEL
A/C CONDENSOR 200-C173 BK-16 F-C1
M933-C151 PU-18
893-K2 GN-18 F889-K15 WH-18 F889-C109 WH-18 261-C143 GN-18 M935-C144 BU-18

M935-C144 BU-18

P946-C149 BR-18

P959-C145 GN-18

WH-16
56 10 6 CANL 6 WASHER SW 8
P946-C157 BR-18

F889-C109 WH-18

M953-C112 BU-18

M953-C164 BU-18

BU-16

WH-18
YL-18
BU-18
BU-18
PS PRESS SOL
PU-18

P943-C37 GN-18
P944-C18 GY-18
P945-C48 OR-18
P949-C36 PU-18
P955-C47 BU-18
P957-C31 BR-18
P958-C12 PK-18
235-C188 BK-18

BU-18
PK-18
147-C181 PU-18

310-C158 PU-18
317-C106 YL-18

892-C115 BR-18
893-C117 GN-18
H807-C57 YL-18
K924-C56 YL-18
M935-C60 BU-18
P944-C59 GY-18

403-C195 GN-18

403-C140 GN-18
403-C196 GN-18

892-C113 BR-18
893-C116 GN-18
C472-C39 GN-18
E456-C43 WH-18
G426-C46 WH-18
H441-C49 GN-18
H446-C45 PK-18
M937-C41 GN-18
M938-C42 GY-18
M953-C99 BU-18
M953-C94 BU-18

M953-C94 BU-18
E789-C38 PU-18
PU-18
PU-18
PK-18
PK-18
PK-18
BU-18
YL-18
BR-18
WH-18
YL-18
PK-18
BU-18
GN-18
GN-18
GN-18
GN-18
BU-18
BR-18
OR-18
YL-18
OR-18
YL-18
OR-18
YL-18
BR-18
PK-18
M933-C44 PU-18
M933-C70 PU-18

BK-14
BK-14
YL-16
YL-16
YL-16
GY-18
BU-18
BU-18

PU-16
BR-18
BR-18
BR-18
893-C118 GN-18
893-C193 GN-18
893-C194 GN-18
BR-18

YL-18

OR-18
YL-18
OR-18
YL-18
OR-18
YL-18
BR-18
PU-18
BU-14
BU-16

168-C52 RD-10
172-C65 RD-18

1636659 2277576
322-C55 GY-18
616-C62 BU-16
709-C61 OR-16

403-C88 GN-16

497-C95 OR-18
788-C98 YL-18

321-C13 BR-18

OR-18
PK-18
GN-18
WH-18

PK-18
998-K1 BR-18 F716-K11 WH-18 F716-C110 WH-18 1449712 251-C141 YL-18 892-C113 BR-18 12V/7A SOCKET A
RD-4
RD-4

304-C96 WH-8

57 11 7 CAT DATA LINK (-) UNUSED 7 INT-2 7

E 58 F716-K11 WH-18 308-K16 YL-16 12 308-C111 YL-16 BK-14 C-C24 251-C135 YL-18 893-C116 GN-18 8 CAT DATA LINK (+) UNUSED 8 1210987 INT-1 6 A1 ACC E
USER DEFINED SHUTDOWN 59 F716-K11 WH-18 F717-K5 YL-18 1552267 261-C156 GN-18 M948-C120 BR-18 9 JOYSTICK GND SWING PUMP SWASH 9 P959-C145 GN-18 130-C154 RD-14 GND 5 A2 GND
F718-K6 BU-18 CONN 4 + 514-C176 PU-16 261-C143 GN-18 H704-C66 PK-18 A3 CAN3 +

C506-C129
60 A 10 TEMP SENSOR POWER UNUSED 10 MOT WASH 4

K909-C128

F716-C110
F717-C107
F718-C108
G976-C166
147-C163
101-C97
109-C91

C468-C86
E554-C89
E789-C69

E790-C33

235-C190
235-C189

K943-C78
E789-C76
E790-C75
E790-C68

K907-C28
E998-C30
F853-C29
H716-C27
H807-C15
H704-C66
K927-C14
K928-C11
K929-C26
K930-C24
K931-C25
K932-C34
K934-C35
K943-C21
K944-C20
K946-C23
K947-C22
K949-C19
K950-C16
K952-C17
L982-C32

308-C184
308-C183
308-C111
405-C100
412-C169
430-C162

514-C176
892-C114
892-C191
892-C192

998-C102

H807-C77

K944-C79
K946-C80
K947-C81
K949-C82
K950-C83
K952-C84
147-C53
102-C93
140-C64

487-C71
491-C74
495-C73
496-C72

607-C54
-B 61 229-K12 BK-14 F889-K15 WH-18 MOTOR B C506-C129 WH-16 497-C95 OR-18 11 +8V-SEN TRAVEL ALARM 11 321-C13 BR-18 130-C1 RD-14 3 A4 CAN3 -
200-C177 BK-16 251-C63 YL-18 M953-C94 BU-18 K927-C14 BU-18 130-C4 RD-14 A5

1
62 - C 12 SENSOR RETURN PROD DR RET 12 WIPER SW 2 CAN3 SHIELD
(Dimensions: 39 inches x 24 inches)

-B 63 229-K13 BK-14 M947-C122 OR-18 13 JOYSTICK +12V PROD DR RET 13 E789-C38 PU-18 130-C6 RD-14 F-C29 WINDOW SW 1 A6 AIR CLEANER SW
64 BK-14 261-C58 GN-18 M950-C125 PU-18 14 LH JOYSTICK (Y-AXIS) STICK (EXTEND) 14 K930-C24 GN-18 1532602 F-C26 A7 CAPSULE FILTER SW
-B 65 229-K14 BK-14 A755-C136 PK-18 M956-C126 GN-18 15 TRAVEL RIGHT PEDAL BUCKET (EXTEND) 15 K931-C25 GN-18 131-C153 RD-14 1886406 A8 SP FILTER SW
THROTTLE 66 F889-K15 WH-18 A756-C137 BU-18 M960-C127 PU-18 16 RIGHT ATT PEDAL BUCKET (RETRACT) 16 K929-C26 GN-18 131-C8 RD-14 GROUND-CAB 1 A9 WTR SPR LEVEL SW
67 A757-C132 GY-18 17 KEY PAD UNUSED 17 131-C10 RD-14 A10
68 L90 A758-C133 BR-18 251-C135 YL-18 18 CANH PROD DR RET 18 H716-C27 WH-18 151-C148 GN-16 A11
69 D-C2 A768-C142 BU-16 19 CAN SHLD SWING BRAKE SOL 19 K907-C28 BU-18 801-C147 PK-18 A12
IGNITION KEY SW 70 308-K16 YL-16 T858-D13 GY-16-KYNAR 1 INJECTOR SOLENOID 1 K847-C155 PU-18 20 ANGL/PWM 5K TRAVEL SPEED SHIFT SOL 20 F853-C29 BR-18 E997-C150 BR-18
T957-D1 PU-16-KYNAR 2 K848-C197 WH-18 M945-C124 BR-18 21 LEVER TOP SW FLOW CONT RH-L UNUSED 21 K927-C14 BU-18 12/7A SOCKET B 1
BRAKE SOLENOID L/H 1 K738-B41 GN-16-HV CONN 1 T858-D7 GY-16-KYNAR L919-C139 YL-18 M942-C171 WH-18 22 LEVER TOP SW FLOW CONT LH-R GND 22 235-C3 BK-14 H704-C66 PK-18 1210987 2 OLWD CANCEL SW
2 B-C13 D-C1 D-C3 L972-C138 BU-18 K847-C155 PU-18 23 ANGL/PWM 5K +B 23 130-C4 RD-14 321-C13 BR-18 3 OPTION STG SW
3 T957-B20 PU-16-HV 1 T957-D1 PU-16-KYNAR T858-D14 GY-16-KYNAR 1 INJECTOR SOLENOID 2 L76 L86 M942-C171 WH-18 M963-C130 BU-18 24 RH JOYSTICK (Y-AXIS) RADIATOR FAN SPEED 24 E998-C30 YL-18 E789-C38 PU-18 4
4 T958-B19 YL-16-HV 2 T958-D2 YL-16-KYNAR T958-D2 YL-16-KYNAR 2 M943-C165 YL-18 M949-C131 PK-18 25 LH JOYSTICK (X-AXIS) ATT EXTEND 25 P957-C31 BR-18 E790-C33 PK-18 5
M944-C146 BU-18 E998-C30 YL-18

1
5 T959-B17 BR-16-HV 3 T959-D3 BR-16-KYNAR 26 UNUSED SPI LOAD 26 6
RENR7307-02

6 T960-B24 BU-16-HV 4 T960-D3 BU-16-KYNAR D-C4 M945-C124 BR-18 788-C98 YL-18 27 ENG SPEED SPI DATA 27 F853-C29 BR-18 F-C30 7
7 T961-B16 GN-16-HV 5 T961-D5 GN-16-KYNAR T859-D16 WH-16-KYNAR 1 M947-C122 OR-18 A757-C132 GY-18 28 THROTTLE DIAL S3 UNUSED 28 H716-C27 WH-18 PLATFORM-CHASSIS 1532602 8 OPTION ROCKER SW
BRAKE SOLENOID M/H 8 K737-B4 BR-16-HV T962-B25 WH-16-HV 6 T962-D6 WH-16-KYNAR T959-D3 BR-16-KYNAR 2 INJECTOR SOLENOID 3 M948-C120 BR-18 A758-C133 BR-18 29 THROTTLE DIAL S4 UNUSED 29 H807-C15 YL-18 STRAP PA 7G1060 9 WASHER
M949-C131 PK-18 151-C148 GN-16 L62 K907-C28 BU-18
9 T858-B15 GY-16-HV 7 T858-D7 GY-16-KYNAR T859-D8 WH-16-KYNAR 30 HAMMAR 2 SPEED SW HYD LOCK SW 30 10 WIPER INT-3
10 T859-B21 WH-16-HV 8 T859-D8 WH-16-KYNAR D-C5 M950-C125 PU-18 L80 K848-C197 WH-18 31 ANLG/PWM 5K CTWT REMOVAL SW 31 L982-C32 PK-18 K909-C128 BU-16 11 WIPER INT-6
11 T860-B14 OR-16-HV 9 T860-D9 OR-16-KYNAR T859-D15 WH-16-KYNAR 1 INJECTOR SOLENOID 4 M954-C119 BU-18 32 DIR/PASSIVE (2+) LOW CUR SINK DR1 32 K928-C11 GN-18 12 WIPER LOW
12 K737-B4 BR-16-HV 10 T960-D4 BU-16-KYNAR 2 M956-C126 GN-18 33 DIR/PASSIVE (2-) LOE CUR SINK DR2 33 K929-C26 GN-18 13 CHAS LAMP RELAY
COOLANT TEMPERATURE 995-B11 BU-18 K738-B41 GN-16-HV 11 M957-C152 GY-18 34 RS232 RX2 34 K930-C24 GN-18 14
WH-16

BU-18
BU-18

WH-18
YL-18
WH-18

H807-C161 YL-18

OR-18

YL-18

OR-18

K947-C180 YL-18

K949-C174 OR-18
K950-C170 YL-18

BR-18

PU-18
BU-18

BU-18

P946-C157 BR-18
P946-C149 BR-18
P946-C179 BR-18

M953-C112 BU-18

P959-C145 GN-18
13 LOW CUR SINK DR3 BOOM LAMP RELAY
PU-18
PU-18
BU-18
BU-18
PU-16

BK-18
BK-16
200-C173 BK-16

BK-18
BK-14

BK-14

YL-16
YL-18
GY-18
BR-18
BR-18
BR-18
BR-18
GN-18
GN-18
GN-18
GN-18
BR-18
BU-18
PK-18

BU-18
200-C187 BK-18
200-C185 BK-18
200-C186 BK-18
E789-C76 PU-18
E790-C75 PK-18
F853-C29 BR-18
H807-C57 YL-18
H807-C77 YL-18
H807-C15 YL-18

YL-18
BU-18
GN-18
GN-18
GN-18
GN-18
OR-18
OR-18

K944-C20 YL-18
K944-C79 YL-18

OR-18
OR-18

K947-C81 YL-18
K947-C22 YL-18

K949-C82 OR-18
K949-C19 OR-18

K950-C83 YL-18
K950-C16 YL-18

BR-18
BR-18

BU-18

GN-18
GY-18
GN-18
GY-18
GY-18
GY-18
P945-C48 OR-18

P949-C36 PU-18
P955-C47 BU-18
P957-C31 BR-18
P958-C12 PK-18
H704-C66 PK-18

C472-C39 GN-18
E456-C43 WH-18
E789-C69 PU-18
E998-C30 YL-18
G426-C46 WH-18
K932-C34 BU-18
K934-C35 BR-18
L982-C32 PK-18

M933-C70 PU-18
H441-C49 GN-18
H446-C45 PK-18
H716-C27 WH-18

308-C183 YL-16
403-C195 GN-18
892-C191 BR-18
893-C193 GN-18
235-C188 BK-18
E790-C68 PK-18
K907-C28 BU-18
GROUND-CHASSIS 7 GROUND-PLATFORM 2
BK-18
BK-18

BK-18
BK-18
BU-14

GN-16
YL-18

321-C13 BR-18

147-C53 PU-18
168-C52 RD-10

496-C72 WH-18
497-C95 OR-18
607-C54 PK-18
709-C61 OR-16

172-C65 RD-18
140-C64 BU-16

322-C55 GY-18
487-C71 OR-18
491-C74 PK-18
495-C73 GN-18

616-C62 BU-16
BRAKE COMMON K739-B40 BU-16-HV 12 D-C6 M960-C127 PU-18 35 RS232 RX1 K931-C25 GN-18 15
BK-4
BK-4

RD-4
RD-4
WH-8

14 K739-B40 BU-16-HV SPI CLOCK 35 OPTION RELAY

INTAKE MANIFOLD AIR PRESS 15 R746-B18 PK-18 T860-D17 OR-16-KYNAR 1 INJECTOR SOLENOID 5 M962-C40 YL-18 36 SUCTION SHUT OFF ON/OFF RET 36 H807-C15 YL-18 K932-C34 BU-18 16
16 T961-D5 GN-16-KYNAR 2 M963-C130 BU-18 37 SUCTION SHUT OFF ON/OFF RET 37 E790-C33 PK-18 K934-C35 BR-18 F-C27 17
PRESSURE SENSOR COMMON 17 G829-B2 GN-18 T860-D9 OR-16-KYNAR M953-C164 BU-18 A755-C136 PK-18 38 THROTTLE DIAL S1 BUCKUP SW 38 K909-C128 BU-16 K943-C21 OR-18 9W1951 18
C506-C129
G976-C166

F716-C110
F717-C107
F718-C108
F889-C109

K943-C178

K944-C175

K946-C182

K952-C172

M933-C151
M935-C144

M935-C168
200-C87
200-C87

101-C97
109-C91
304-C96
147-C163
310-C158
412-C169
430-C162
514-C176

235-C167
200-C173

235-C167
229-C101

229-C101

308-C111
317-C106
405-C100
892-C103
892-C114
892-C115
892-C113
893-C117
893-C116
893-C118
893-C104
998-C102
C468-C86
E554-C89

M953-C99

K924-C56
K927-C14
K928-C11
K929-C26
K930-C24
K931-C25
K943-C78
K943-C21

K946-C23
K946-C80

K952-C84
K952-C17

M935-C60

M937-C41
M938-C42
P943-C37
P944-C59
P944-C18
P944-C85
200-C92
235-C90

235-C90
200-C92
102-C93

403-C88
788-C98

18 D-C7 403-C140 GN-18 A756-C137 BU-18 39 THROTTLE DIAL S2 STB 4 39 K944-C20 YL-18 B F-C2
19 T860-D18 OR-16-KYNAR 1 INJECTORSOLENOID 6 40 DIR/PASSIVE (1+) SWING (LH) 40 K932-C34 BU-18 K946-C23 OR-18 D F-C16 F-C11 1636699
20 T962-D6 WH-16-KYNAR 2 41 DIR/PASSIVE (1-) SWING (RH) 41 K934-C35 BR-18 K947-C22 YL-18 E F-C18 1636803 F-C4 F-C28
403-C196 GN-18 K949-C19 OR-18 A F-C17 1636803 1636803 1636803 7Y3967
D 21 42 RS232 TX2 GAIN/RESPONSE IND2 42 CONN 40 D
22 C-C32 497-C95 OR-18 43 RS232 TX1 GAIN/RESPONSE IND1 43 K950-C16 YL-18 C 1636803 1

4
3
2
1
5

4
3
2
1
5

4
1
3
2
5

4
1
3
2
5
23 1552269 788-C98 YL-18 44 UNUSED AUTO LUB RELAY 44 801-C147 PK-18 K952-C17 BR-18 F

4
3
1
2
5
24 B-C2 K-C12 K907-C28 BU-18 1 SWING BRAKE 892-C113 BR-18 L972-C138 BU-18 45 ONE TOUCH LOW IDLE SW SYSTEM PRESS SOL 45 P949-C36 PU-18 L982-C32 PK-18 G F-C24
PASSIVE -1 A CRANK SPEED 25 E963-B23 BK-18 E790-C68 PK-18 2 SOL 1211491 893-C116 GN-18 46 NEUTRAL SW LH-X GND 46 235-C5 BK-14 M933-C44 PU-18 H 7Y3967
TDC PROBE+ 26 G856-B8 WH-18 1552269 3E3364 L64 L81 C472-C39 GN-18 L919-C139 YL-18 47 MANUAL LUB SW +B 47 130-C6 RD-14 M935-C144 BU-18 J 1
27 G856-B8 WH-18 1 TDC PROBE CONN 3 E456-C43 WH-18 48 BACK LIGHT LOWERING CHECK STICK 48 P943-C37 GN-18 P943-C37 GN-18
OIL PRESSURE SENSOR 28 994-B10 GY-18 G857-B9 YL-18 2 L83 GND CHASSIS 4 F889-C109 WH-18 49 GAIN/RESPONSE SELECT SW PROD DR RET 49 P944-C18 GY-18 F-C25
29 G426-C46 WH-18 M943-C165 YL-18 50 LEVEL TOP SW CONT LH-L MED.PRESS CIRCUIT 1-A 50 P945-C48 OR-18 7Y3967
TEMPERATURE SENSOR COMMON 30 G833-B7 PK-18 G833-B7 PK-18 G833-B36 PK-18 H441-C49 GN-18 51 AMBIENT TEMP SENSOR BOOM (EXTEND) 51 K950-C16 YL-18 P946-C149 BR-18 1
P944-C85 GY-16
P943-C37 GN-18

PK-18

M937-C41 GN-18
M938-C42 GY-18
BR-18

PU-18
PK-18
BU-18
GN-18
YL-18
BR-16
GN-18
BU-18
OR-18

B-C4
PK-18
PU-18

PU-18

F853-C29 BR-18
K947-C180 YL-18
K944-C175 YL-18
BR-18

YL-18
BU-18

200-C186 BK-18
OR-18
GN-18
OR-18
OR-18
GN-18
BK-18

ATCH SEAT HEATER SW ATCH OLWD WARNING DEVICE SW ATCH RADIO MUTE ATCH MANUAL LUB SW
BR-18

H446-C45 PK-18 C472-C39 GN-18 K952-C17 BR-18 P949-C36 PU-18

YL-16

31 G833-B37 PK-18 L195 52 PUMP PRESS SENSOR PROD DR RET 52

32 G833-B38 PK-18 3E3370 147-U4 PU-18 M937-C41 GN-18 53 NEUTRAL SW (HAMMER PEDAL) UNUSED 53 P955-C47 BU-18 2382211 2382215 2382216 2382218
33 G828-B31 WH-18 A OR +5V ATMOSPHERIC M938-C42 GY-18 54 FLOW CONT ROCKER SW DRIFT REDUCTION VALVE 54 P946-C149 BR-18 P957-C31 BR-18
34 G829-B32 GN-18 G829-B32 GN-18 B BK GROUND PRESSURE ATCH CWTE REMOVAL SW 2434506 AH-C1 J-C21 M953-C94 BU-18 M937-C41 GN-18 55 AUX 1WAY 2WAY LIMIT SW 1 HYDRAULIC LOCK SOL 55 E997-C150 BR-18 P958-C12 PK-18 IDENT PART NO. LOC IDENT PART NO. LOC
M935-C168
K950-C170
M933-C151
K952-C172

H807-C161

P958-C12
K949-C174

K943-C178
P957-C31

P949-C36
H704-C66
K930-C24

K931-C25
P955-C47
P945-C48
K946-C182
E790-C75
E789-C76
K927-C14

K929-C26
K928-C11
200-C185

1140521 U-C1
321-C13

P946-C179

M938-C42 GY-18 235-C7 BK-14 P959-C145 GN-18 616-N3 BU-16 ATCH BOOM LAMP LH
K924-C56

PASSIVE +1 A CRANK SPEED 35 E964-B22 WH-18 G829-B2 GN-18 G829-B33 GN-18 R747-B5 GY-18 C YL SIGNAL SENSOR 1946722 2434506 2304013 56 AUX 1WAY 2WAY LIMIT SW 2 GND 56
TDC PROBE- 36 G857-B9 YL-18 G829-B34 GN-18 147-U4 PU-18 1 147-AH1 PU-18 147-J49 PU-18 E456-C43 WH-18 57 AUTO LUB LOW LEVEL +B 57 131-C8 RD-14 235-C188 BK-18 200-N4 BK-16 1532521 HARNESS AS. WIRE AS. CONT.
37 G829-B35 GN-18 2 3 L982-U1 PK-18 L982-U1 PK-18 2 1 A768-C142 BU-16 58 KEY SW LOWERING CHECK BOOM 1 58 P944-C18 GY-18 J-C4 J-C26 N-C1
B-C5 1 L981-U2 YL-18 200-U3 BK-18 3 2 L982-J49 PK-18 M944-C146 BU-18 M933-C44 PU-18 235-C189 BK-14 2304011 2434505 2434505 WJ 234-1193 H-12
38 5 6 3 200-J44 BK-18 59 LEVER TOP SW FLOW CONT RH-R PROD DR RET 59 A 251-0520 K-8
COOLANT FLOW SWITCH 39 N708-B39 BR-18 G828-B28 WH-18 1552269 INTAKE MANIFOLD H441-C49 GN-18 60 AUTO LUB PRESS. SENSOR MED,PRESS CIRCUIT 1-B 60 616-J22 BU-16 1 1 616-N1 BU-16 616-N5 BU-16 ATCH BOOM LAMP RH WK 163-6758 L-12
FUEL PRESSURE C991-B6 PK-18 G828-B1 WH-18 G828-B29 WH-18 995-B13 BU-18 4 H446-C45 PK-18 61 BOOM BTM PRESS SENSOR 61 K949-C19 OR-18 235-C9 BK-14 200-J23 BK-16 200-N9 BK-16 200-N6 BK-16 B 239-5929 C-17
40 1 SIGNAL AIR TEMP 8 9 CONN 11 147-J49 PU-18 C-C3 C-C4 C-C5 C-C30 BOOM (RETRACT) 2 CONN 52 2 1532521 WL 238-2440 C-6
41 G828-B30 WH-18 G833-B38 PK-18 2 GROUND SENSOR 1309811 7 2434510 2304009 2312295 2304013 G426-C46 WH-18 62 SWING PUMP PRESS SENSOR LH TRAVEL (FRONT) 62 K944-C20 YL-18 235-C7 BK-14 C 267-8049 K-8
42 G828-B31 WH-18 11 12 147-J53 PU-18 63 STG 29 LH TRAVEL (REAR) 63 K943-C21 OR-18 J-C3 D 307-1611 D-16 CABLE AS.
10
11
12

10
11
12

CONN 12 CONN 13 CONN 14 C-C27

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8

1
2
3

43 B-C6 10 147-J17 PU-18 64 STG 28 RH TRAVEL (FRONT) 64 K947-C22 YL-18 235-C190 BK-14 9X4813 ATCH ELE LUB PUMP E 224-2862 H-14
44 147-J11 PU-18 L-C25 2434506 65 STG 27 RH TRAVEL (REAR) 65 K946-C23 OR-18 235-C5 BK-14 A A 1056989 CA 227-7049 J-18
1552269 L-C26 L-C27 66 STG 26 66 P955-C47 BU-18 235-C2 BK-14 140-J26 BU-16 B ON (KEY) F 267-7682 G-4 CC 8V-0622 J-17
45 2304009 2434510 2434509 NEUTRAL FLOW BYPASS B
PASSIVE +2 B CAM SPEED 46 E966-B26 YL-18 994-B10 GY-18 E963-B23 BK-18 1 S/T - CRANKSHAFT SPEED U-C2 J-C12 67 ATT PUMP PRESS SW DRIFT REDUCTION VALVE STICK 67 P945-C48 OR-18 235-C3 BK-14 200-J27 BK-16 C C GND G 251-0601 J-4 CE 227-7050 J-17
BR-18
PK-18
PU-18
YL-18
BU-18
PU-18

K947-L31 YL-18
K944-L33 YL-18
F853-L21 BR-18

BU-18
GN-18
YL-18
BR-16
GN-18
BR-18
BU-18
OR-18

PU-18
PK-18

P943-L27 GN-18
P944-L25 GY-16

PK-18
YL-16

CONN 15 SYMBOL DESCRIPTION

BK-18

BR-18

OR-18
GN-18

OR-18
GN-18
OR-18

1552269 PUMP PRESS. SENSOR H 259-5098 L-4

1
2
3

PASSIVE -2 B CAM SPEED 47 E965-B27 BU-18 995-B11 BU-18 E964-B22 WH18 2 S/T + SENSOR 1899266 1552267 68 AUTO LUB PISTON STICK UNUSED 68
48 C967-B13 BU-18 1 L981-U2 YL-18 2218859 147-J11 PU-18 69 AUTO LUB PISTON SWING GND 69 235-C9 BK-14 J 251-0521 B-9 CF 227-7135 H-18 (NOTE B)
C991-B6 PK-18 2 200-U3 BK-18 +B 1 AN-C1 70 AUTO LUB PISTON BUCKET 70 131-C10 RD-14 J-C5 J-C29 ATCH AUTO LUB PRESS.SENSOR CG 8V-0622 H-18 (NOTE B)
49 B-C7 GROUND 2 M953-J3 BU-18 2434506 +B K 224-2896 E-16
50 E963-B23 BK-18 C472-J2 GN-18 2304013 2434506 2475177 CIRCUIT CONNECTED CH 227-7134 H-17 (NOTE B)
K952-L44
E790-L50
E789-L47
H807-L46
K927-L45
M933-L28

M935-L19
K930-L35
K950-L37
P946-L13
K931-L39
P957-L41
P955-L15
P945-L29

P949-L23
H704-L52

P958-L11
K924-L17

SIGNAL 3 L 231-1664 C-13

200-L53

321-L48

K946-L1
K928-L5

K949-L7
K929-L9
K943-L3

51 E964-B22 WH-18 1552267 ATCH CWTW REMOVAL CONT SOL1 140-J24 BU-18 1 1 +B
M937-AN3 GN-18
M938-AN5 GY-18

M 251-0543 H-1 CP 234-1018 J-18 (NOTE B)

200-AN1 BK-18

52 E965-B27 BU-18 G828-B30 WH-18 A OR +5V INTAKE 1269992 L82 J-C6 J-C30 200-J48 BK-18 2 2 GROUND
53 E966-B26 YL-18 G829-B34 GN-18 B BK GROUND AIR PRESSURE 1552267 3E3370 H441-J4 GN-18 3 3 SIGNAL N 251-0577 C-4 CR 2341017 I-18 (NOTE B)
54 F421-B12 YL-18 R746-B18 PK-18 C WH SIGNAL 147-J52 PU-18 A A +B CIRCUIT NOT CONNECTED N 251-0578 C-4 (NOTE C)
55 G856-B8 WH-18 SENSOR 2393478 SWING PUMP PRESS. SENSOR J-C13
1552267 M953-J45 BU-18 B CONN 34 B GROUND OLWD PRESS SENSOR BOOM
2218859 P 251-0576 B-4 STRAP AS.
C INTAKE MANIFOLD AIR TEMP 56 C967-B13 BU-18 G857-B9 YL-18 2218859 +B H446-J46 PK-18 C C SIGNAL J-C2 J-C27 ATCH AUTO LUB PUMP C
B-C8 1 147-J17 PU-18 ELECTRICAL CONNECTION TO R 167-3456 G-2 PA 7G-1060 D-6

P959-C145 GN-18
ATMOSPHERIC PRESSURE SENSOR R747-B5 GY-18 N707-B43 PU-18 1552269 3E3364 2022916

M953-C112 BU-18
57

G426-C46 WH-18
M953-J6 BU-18 L32

C472-C39 GN-18
H441-C49 GN-18

E998-C30 YL-18
H716-C27 WH-18
2

H446-C45 PK-18
GROUND

L982-C32 PK-18
E789-C69 PU-18

K932-C34 BU-18
M933-C70 PU-18
K934-C35 BR-18
L56 R 170-9295 G-2 (NOTE D) PC 128-8886 G-18

709-C61 OR-16
140-C64 BU-16
322-C65 GY-16
616-C62 BU-16

487-C71 OR-18
496-C72 WH-18
495-C73 GN-18
491-C74 PK-18

168-C52 RD-10
1552269

E456-C43 WH-18

497-C95 OR-18
58 N708-B39 BR-18 L52 709-J28 OR-16 1 1 ON (KEY)

607-C54 PK-18
147-C53 PU-18
CAMSHAFT SPEED SIGNAL 3 G426-J5 WH-18 ATCH AUX 1WAY 2WAY LIMIT SW 1 200-J29 BK-16
MACHINE STRUCTURE
T 234-1183 A-7
59 R746-B18 PK-18 E965-B27 BU-18 1 BK S/T - 2 2 GND PE 132-1805 G-16
60 R747-B5 GY-18 E966-B26 YL18 2 WH S/T + SENSOR 2016617 AN-C2 3E5181 140-J51 BU-16 INTERNAL ELECTRICAL CONNECTION U 238-2122 C-14
61 T725-B44 WH-18 200-AN1 BK-18 1552272 1 2 140-J24 BU-18 ATCH REFUELING LEVEL SW WL-C1 J-C25 J-C8 L33 J-C1 J-C28 V 255-3067 B-15
FUEL TEMPERATURE SENSOR 62 F421-B12 YL-18 B-C9 J-C14 1 4 3 140-J30 BU-16 5C6108 2304011 2434505 1552267 3E3370 A ON (KEY) TO SURFACE OF COMPONENT
X 238-1637 A-6 COLOR ABBREVIATIONS
63 200-AN2 BK-18 4 140-J26 BU-16 2304011 140-J30 BU-16 A B GND
3E3370 1552269 M937-AN3 GN-18 3 322-J33 GY-16 325-WL1 PK-18 1 1 325-J39 PK-18 200-J31 BK-16 Y 238-1595 A-4
64 SWING PUMP SWASH SOL P959-J7 GN-18 2 CONN 39 B C SIG
PU-18
PU-18
PU-18
PU-18
PK-18
PK-18
PK-18
BR-18
PK-18
YL-18
YL-18
YL-18
YL-18
YL-18
YL-16
BU-18
BU-18

BU-18

GN-18
GN-18

YL-18
YL-18
YL-18

BR-18
BR-18
BR-18
BR-18
BR-18
BR-18
BR-18
PU-18
BU-18
GN-18
GY-16
OR-18
BR-16
PU-18
BU-18
BR-18
PK-18

1 2
BR-18

BU-18

GN-18
GN-18

OR-18
OR-18

OR-18
BR-18
BR-18
BR-18

200-L53 BK-18
200-L18 BK-18
200-L51 BK-18

DIFFERENTIAL FUEL PRESS SW 65 T725-B44 WH-18 G828-B29 WH-18 A OR +5V ENGINE 2161397 2 H716-J8 WH-18 L53 2 L59 607-J35 PK-18 168-J37 RD-10 E456-J32 WH-18 C CONNECTOR AA 238-1597 A-4 ABBREV COLOR
66 G829-B33 GN-18 B BK GROUND OIL PRESSURE C-C6 C-C7 C-C9 C-C18 616-J22 BU-16 L60 200-J40 BK-18 AH 238-2420 C-14 (NOTE E)
67 994-B10 GY-18 C YL SIGNAL 2434510 709-J28 OR-16 J-C31 P-C1 AJ 234-1124 F-5 RD RED
SENSOR 1946725 ATCH AUX 1WAY 2WAY LIMIT SW 2 2434509 2304009 1343296 E456-J32 WH-18 L32 200-J38 BK-10 2304011 2434505
68 J-C15 CONN 24 AL 259-5008 G-9
E789-L42
E789-L40
E789-L36
E789-L47
E790-L22
E790-L49
E790-L50
F853-L21
H704-L52
H807-L24
H807-L16
H807-L14
H807-L30
H807-L46
K924-L17
K927-L12
K927-L10

K927-L45

K930-L35
K931-L39

K944-L33
K947-L31
K950-L37

K952-L20
K952-L43
K952-L38
K952-L34
K952-L32
K952-L26
K952-L44
M933-L28
M935-L19
P943-L27
P944-L25
P945-L29
P946-L13
P949-L23
P955-L15
P957-L41
P958-L11

10
11
12
CONN 22 CONN 23

10
11
12
321-L48

K927-L6

K928-L5
K929-L9

K946-L1
K943-L3

K949-L7
K952-L4
K952-L2
K952-L8

AN-C3 3E5181 CONN 21 H441-J4 GN-18 322-J33 GY-16 322-P1 GY-16 H# CIRCUIT GROUPING DESIGNATION
1
2
3
4
5
6
7
8

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9
69 B-C10 1552269 J-C16 1 AM 238-1640 L-16
WH WHITE
70 RADIATOR FAN SPEED CONT SOL 1 E998-J9 YL-18 1552272 1 2 J-C17 J-C22 J-C20 200-J48 BK-18 200-J1 BK-16 2 322-P2 GY-18 HORN LH LOW
71 1552269 1 2312295 2434510 1343295 2304009 200-J23 BK-16 200-P3 BK-16 2130710 AN 238-2389 B-11 OR ORANGE

200-J38 BK-10
168-J37 RD-10
ENGINE
20 Page,

2095939 2 E789-J10 PU-18 4 3

325-J39 PK-18
200-J40 BK-18
PRESSURE SENSOR +5V 72 G828-B1 WH-18 995-B11 BU-18 1 SIGNAL COOLANT TEMPERATURE 200-AN4 BK-18 4 200-J31 BK-16 CONN 53 200-P4 BK-18 ATCH WIRE, CABLE, COMPONENT GH 259-5256 H-4

PU-18
E456-J32 WH-18

PK-18

L982-J43 PK-18
E789-J10 PU-18

BU-18
BR-18
BU-18

BK-16
BK-18
BK-18
BK-16
BK-18
BK-16
BK-16
BK-16
BK-10
BK-18
BK-18

BK-18
607-J35 PK-18
147-J42 PU-18

C472-J2 GN-18
H441-J4 GN-18

709-J28 OR-16
BU-16
GY-16
BU-16
WH-18
GN-18
OR-18
WH-18
GN-18
PK-18

168-J37 RD-10

YL-18
WH-18

BK-16
BK-18
BK-18
BK-16
BK-16
BK-10
BK-16
BK-18
BK-16
BK-18
G833-B36 PK-18 2 GROUND M938-AN5 GY-18 3 200-J34 BK-16 YL YELLOW
73
SENSOR 1309811 2 200-J27 BK-16
GJ 259-5285 G-15
74 V-C4 ATCH REFUELING RELAY DIODE 200-J36 BK-18 GK 259-4967 F-9 (NOTE F) PK PINK
75 L-C1 200-J29 BK-16 1974385 X-C8 322-P5 GY-18 HORN MID HIGH
76 3E3370 2130711 CIRCUIT CONNECTED GL 259-4969 G-9 (NOTE F)
1552269

M933-J12
H446-J46

K932-J15
K934-J13
M953-J55
L49 BK BLACK

200-J34
200-J44
200-J48
200-J29
200-J40
200-J27

200-J38
235-J54
200-J23
200-J31

235-J20

235-J20
GN 259-4968 F-8 (NOTE F)

140-J51
322-J33
616-J22
G426-J5
P959-J7
487-J21
496-J18
495-J41
491-J19

E998-J9
H716-J8

200-J27
200-J44
200-J48
200-J34
200-J23
200-J38
200-J29
200-J40
200-J31
235-J54
77 CONN 2 G828-V5 WH-18 A OR +5V FUEL PRESSURE TRAVEL RH SOL REAR K946-L1 OR-18 168-J37 RD-10 L33 1552269 200-P6 BK-18
78 G829-V6 GN-18 B BK GROUND 1 200-J40 BK-18 1 168-X14 RD-18 J-C10 200-J34 BK-16
SENSOR 1946725 1482350 2 K952-L2 BR-18 200-J38 BK-10 329-X15 YL-18 J-C9 607-J35 PK-18 322-P5 GY-18 HORN RH LOW WIRE AS.
GY GRAY
79 C991-V7 PK-18 C YL SIGNAL 2 2304011 BLADE, SPADE, RING OR SCREW
80 FUEL LEVEL SENSOR1 1160126 2130710 WA 234-1198 H-12 PU PURPLE
81 F421-B12 YL-18 F421-V1 YL-18 J-C7 1636700 J-C11 TERMINAL
YL-18
YL-18
BU-18
BU-18

BR-16
BU-18
PK-18
PK-18
BR-18
PK-18
YL-16
BR-18
BU-18

PK-18
YL-18
BR-18
PU-18
GN-18
GY-16
PU-18
PU-18
PU-18
PU-18
YL-18
GN-18
GN-18
YL-18
YL-18
YL-18
BR-18
BR-18
BR-18
OR-18
BR-18

L-C4 WC 234-1199 H-12

BU-18
GN-18
GN-18
OR-18
OR-18
OR-18
BR-18
BR-18
BR-18

BK-18
BK-18
BR-18

V-C2 1552269 J-C19 2434505

1
2

1
2
82 G833-B37 PK-18 G833-V2 PK-18 1552269 WE 234-1197 K-13
BR BROWN
DIFF FUEL PRESS SW RETURN 83 N707-B43 PU-18 T725-B44 WH-18 T725-V3 WH-18 1552269 FUEL DIFFERENTIAL TRAVEL LH SOL REAR 1 K943-L3 OR-18 495-J41 GN-18 1 ATCH REFUELING POWER RELAY CONN 38 1211038 CONN 37 200-J36 BK-18
84 N707-B43 PU-18 N707-V4 PU-18 T725-V3 WH-18 1 BK L-C18 235-J54 BK-18 2 2130722 CHASSIS LAMP 2 SPLICE WF 234-1195 K-13 GN GREEN
PRESSURE 1482350 2 K952-L4 BR-18 1552269 168-X2 RD-18 607-J35 PK-18 1532523
85 G828-B28 WH-18 G828-V5 WH-18 N707-V4 PU-18 2 BK WG 234-1196 K-13
H807-L16
H807-L14
K927-L12
K927-L10

P946-L13
P955-L15
P958-L11
E790-L22
F853-L21
H704-L52
K924-L17
K952-L20
M935-L19

E790-L49
H807-L24
K952-L26
M933-L28
P943-L27
P944-L25
P949-L23
E789-L42
E789-L40
E789-L36
H807-L30
K930-L35
K931-L39
K944-L33
K947-L31
K950-L37
K952-L32
K952-L38
K952-L34
P945-L29
P957-L41
200-L51
K927-L6
K928-L5
K929-L9
K943-L3
K946-L1
K949-L7
K952-L2
K952-L4
K952-L8

200-L18
321-L48

329-X17 YL-18 X-C7 X-C1

1
2

1
2
86 G829-B35 GN-18 G829-V6 GN-18 SWITCH 2122768 P945-L29 OR-18 1 ANTI DRIFT SOL STICK L57 GND CHASSIS 3 WH 234-1194 H-12 BU BLUE
H807-L30 YL-18 2 1890189 J-C24 168-X16 RD-18 1211038 2434505
87 C991-B6 PK-18 C991-V7 PK-18 V-C3 L-C6 323-X5 WH-10 168-X1 RD-10
88 1552269 1552269 168-X3 RD-18
89 1552269 STICK SOL RETRACT 1 K928-L5 GN-18 K934-J13 BR-18 1 SWING RH SOL WIRE GROUP COLOR DESCRIPTIONS
B 90 F421-V1 YL-18 1 SIGNAL FUEL TEMP 1482350 2 K927-L6 BU-18 L-C19 M933-J14 PU-18 2 1125874 B
91 G833-V2 PK-18 2 GROUND SENSOR 1309811 1552269 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.
ATCH REFUELING PUMP

200-X18 BK-18
K947-L31 YL-18 1 TRAVEL RH SOL FRONT J-C23

325-X6 PK-18
92 L35 L37 1654962
93 L-C2 K952-L32 BR-18 2 1482350 1552269 BK-14 X-C6
PU-18

PK-18

M953-J45 BU-18
BU-18

WH-18
PK-18
BU-18
BR-18
PU-18
PU-18
PU-18
BK-18
GN-18
YL-18
WH-18
WH-18
GN-18
BU-18
BU-18
147-J53 PU-18
147-J52 PU-18
147-J42 PU-18

PU-18
BU-16
RD-10
BK-16
BK-16
GY-16
BK-18
BK-10
OR-18
GN-18
WH-18
BU-16
OR-16

BK-16
BK-16
BK-18
BK-16
BK-18
BK-18
PK-18

PK-18

GN-18
94 1552269 ATCH TRAVEL ALARM K932-J15 BU-18 1 SWING LH SOL 1160126 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.
95 L-C3 L-C28 2139100 M933-J16 PU-18 2 1125874 + 1 323-X5 WH-10 THIS SCHEMATIC IS FOR THE 365C EXCAVATOR.
BOOM SOL RETRACT 1 K949-L7 OR-18 1552269 3E3364 L-C20 MOTOR 2 200-X4 BK-10
96 1482350 2 K952-L8 BR-18 VOLTAGE CONVERTER OUTPUT CIRCUIT.
97 321-L48 BR-18 1 1552269 140-J51 BU-16 - ATCH REFUELING 213-0900 CHANGE 03

M933-J12
E789-J10

L982-J43

M953-J55

E456-J32
H446-J46
K932-J15
K934-J13
M933-J14
M933-J16
E790-L49 PK-18
200-J44
C472-J2
E998-J9
G426-J5
H716-J8
P959-J7
M953-J3
M953-J6

147-J42
140-J51
168-J37
200-J34
200-J31
322-J33
200-J40
200-J38
487-J21
491-J19
495-J41
496-J18
607-J35
616-J22
709-J28

H441-J4

200-J23
200-J29
200-J48
200-J27
235-J54
235-J20
98 2 K944-L33 YL-18 1 TRAVEL LH SOL FRONT 147-J52 PU-18 STARTING CIRCUIT.
INJECTOR 5 & 6 HIGH 99 T860-B14 OR-16-HV L-C13 L-C5 K952-L34 BR-18 2 1482350 168-J37 RD-10 BK-14 STOP SW
L-C7 3E3364 1552269 L-C15 HYD OIL LEVEL SW 9X4184
100 1552269 AUTO REVERSE FAN SOL 1 H704-L52 PK-18 1552269
322-J33 GY-16
495-J41 GN-18
T-C1
1552269 1114760 X-C2 AA-C1
2434505 230411 GROUND CIRCUIT. COMPONENTS ARE SHOWN INSTALLED ON A FULLY
101 BUCKET SOL RETRACT 1 K929-L9 GN-18 2426880 200-L51 BK-18 ATCH REFUELING RELAY 2 X-C5
102 1482350 2 K927-L10 BU-18
2 P949-L23 PU-18 1 SYSTEM PRESS. SOL
1890189
L-C21 607-J35 PK-18 496-T1 WH-18 1 1495050 365-X7 YL-18 1 365-AA1 YL-18 OPERABLE MACHINE WITH THE KEY AND ENGINE OFF.
103 H807-L24 YL-18 2 1552269 616-J22 BU-16 L34 235-T2 BK-18 2 1495051 325-X6 PK-18 2 325-AA2 PK-18 STARTING AID CIRCUIT.
INJECTOR 1 & 2 HIGH 104 T858-B15 GY-16-HV L-C11 K930-L35 GN-18 1 STICK SOL EXTEND 709-J28 OR-16 1 L976-X13 GN-18
INJECTOR 6 COMMON 105 T962-B25 WH-16-HV L-C8 1552269 E789-L36 PU-18 2 1482350 E456-J32 WH-18 2 365-X8 YL-18 CONN 36 CAT DATA LINK. REFER TO THE APPROPRIATE SERVICE MANUAL FOR
INJECTOR 3 COMMON 106 T959-B17 BR-16-HV 1552269 HYD LOCK SOL K924-L17 YL-16 L54 H441-J4 GN-18 3 200-X18 BK-18 TROOUBLESHOOTING, SPECIFICATIONS & SYSTEMS
INJECTOR 5 COMMON 107 T961-B16 GN-16-HV 1 ATCH LOWERING CHECK SOL BOOM H446-J46 PK-18 4
ATT SOL RETRACT 1 P958-L11 PK-18 1211491 2 200-L18 BK-18 1710028 L-C22 M953-J45 BU-18 329-X17 YL-18
INJECTOR 4 COMMON 108 T960-B24 BU-16-HV 1482350 2 K927-L12 BU-18 L38
1552269 235-J54 BK-18 HYD OIL TEMP SENDER
5 J1939(CAN) DATA LINK. OPERATIONS.
109 L-C16 L-C29
110 L-C12 L36 K950-L37 YL-18 1 BOOM SOL EXTEND 200-J23 BK-16 4I5394 PRODUCT LINK CONTROL RS232 DATA LINK.
111 1552269 3E3364 K952-L38 BR-18 2 1482350 200-J48 BK-18 235-T7 BK-18
L-C9 1552269 P944-L25 GY-16 1 200-J40 BK-18 NOTE A: WIRE PAIRS MUST BE TWISTED AT LEAST
112 1552269 PS PRESS. SOL 1 M935-L19 BU-18 K952-L26 BR-18 ATCH REFUELING
113 ANTI DRIFT SOL BOOM P946-L13 BR-16 2 200-J38 BK-10 235-T3 BK-18 MONITOR CIRCUIT. 1 TURN PER 25MM.
114 1 1119916 2 K952-L20 BR-18 L-C23 200-J34 BK-16 T° START SW
1890189 2 H807-L14 YL-18
INJECTOR 3 & 4 HIGH 115 T859-B21 WH-16-HV
ATCH LOWERING CHECK SOL STICK
1552269
K931-L39 GN-18 BUCKET SOL EXTEND
200-J27 BK-16 491-T5 PK-18 ATCH REFUELING RELAY 1
1495050
X-C3 Y-C1
2304011 2434505
6T9442 ENGINE CONTROL CIRCUIT. NOTE B: USE WITH COLD WEATHER.
INJECTOR 1 COMMON 116 T957-B20 PU-16-HV L-C14 1 200-J29 BK-16 X-C4
117 L-C10 1552269
1710028 E789-L40 PU-18 2 1482350 L56 200-J31 BK-16 1495051 168-X3 RD-18 1 168-Y1 RD-18 ENGINE PUMP CONTROL CIRCUIT. NOTE C: USE WITH REACH BOOM
A INJECTOR 2 COMMON 118 T958-B19 YL-16-HV 1552269 TRAVEL SPPED SHIFT SOL F853-L21 BR-18 J-C18 T-C4 T-C2 HYD OIL FILTER SW 1 1 L976-X11 GN-18 L976-X10 GN-18 2 L976-Y2 GN-18 NOTE D: USE WITH FOGS CAB A
119 1 L-C17 L-C30 2305008 2434507 1552269 1733518 2 365-X9 YL-18
NEUTRAL FLOW BYPASS SOL 1 P955-L15 BU-18 1211491 2 E790-L22 PK-18 1552269 3E3364 L-C24 496-J18 WH-18 496-T1 WH-18 487-T6 OR-18 168-X2 RD-18
120 1890189 2 H807-L16 YL-18 P943-L27 GN-18 1 1552269 491-J19 PK-18
1
491-T5 PK-18 235-T7 BK-18
2 SIGNAL 3
CONN 35
MACHINE SECURITY CONTROL CIRCUIT. NOTE E: NOT USE ON CTWT REMOVAL.
B-C1 2 1 +GND 4
M933-L28 PU-18 2 P957-L41 BR-18 1 ATT SOL EXTEND 235-J20 BK-18 3 235-T3 BK-18 L28 5 L976-X12 GN-18 HEATER AND AIR CONDITIONER CIRCUIT. NOTE F: USE WITH PRODUCT LINK.
E789-L42 PU-18 2 1482350 487-J21 OR-18 4 487-T6 OR-18
NOTE G: USE WITH JUMP START.
L56 CONN 33 TURN SIGNAL/WIPER/WASHER CIRCUIT. NOTE H: USED ON EARLY SERIAL NUMBERS ONLY.
18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1