Technical Publication

DR-1004R11

LV-DRAC
Low Voltage - Digital Rotating Anode Controller

HF Series Generators
 HF Series Generators
LV-DRAC

REVISION HISTORY

REVISION DATE REASON FOR CHANGE

4 SEP 15, 2005 Tube selection (V10Rx)

5 JUL 26, 2006 New Tubes in Table-2

6 MAR 1, 2007 New Tubes in Table-2 (soft V10R2.04)

7 MAY 16, 2007 New Tubes in Table-2 (soft V10R3.1)

8 OCT 16, 2007 New Tubes in Table-2 (soft V10R3.3)

9 JAN 22, 2008 New Tubes in Table-2 (soft V10R3.4)

10 MAY 12, 2008 New Tubes in Table-2 (soft V10R3.5)

11 JUL 01, 2009 New Tubes and schematics (soft V10R3.6)

This Document is the English original version, edited and supplied by the manufacturer.

The Revision state of this Document is indicated in the code number shown at the bottom of this page.

ADVISORY SYMBOLS
The following advisory symbols will be used throughout this manual. Their
application and meaning are described below.

DANGERS ADVISE OF CONDITIONS OR SITUATIONS THAT

IF NOT HEEDED OR AVOIDED WILL CAUSE SERIOUS
PERSONAL INJURY OR DEATH.

ADVISE OF CONDITIONS OR SITUATIONS THAT IF NOT

HEEDED OR AVOIDED COULD CAUSE SERIOUS PERSONAL
INJURY, OR CATASTROPHIC DAMAGE OF EQUIPMENT OR
DATA.

Advise of conditions or situations that if not heeded or

avoided could cause personal injury or damage to equipment
or data.

Note . Alert readers to pertinent facts and conditions. Notes represent

information that is important to know but which do not necessarily
relate to possible injury or damage to equipment.

DR-1004R11
 HF Series Generators
LV-DRAC

TABLE OF CONTENTS

Section Page

1 CONFIGURATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

1.1 LV-DRAC Status Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

1.2 Self-running Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

2 SCHEMATICS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

DR-1004R11 i
HF Series Generators
LV-DRAC

ii DR-1004R11
 HF Series Generators
LV-DRAC

SECTION 1 CONFIGURATION

Note . This document ONLY applies to High Speed Generators supplied

with the LV-DRAC (Low Voltage - Digital Rotating Anode
Controller).

The LV-DRAC is a High Speed Rotor Controller located on the Generator

Cabinet. Its configuration is made through dip switches 3243SW1 to 3243SW4
on the Control DRAC Board.

BEFORE MANIPULATING THE LV-DRAC, MAKE SURE THAT

THE INPUT LINE IS DISCONNECTED AND THE CAPACITOR
BANK IS PROPERLY DISCHARGED. WAIT UNTIL LEDS DL7
AND DL8 ON THE CONTROL DRAC BOARD ARE OFF.

The Function of these switches is the following:

3243SW1-x FUNCTION

2 MINIMUM TIME FOR READY (DELAY)

( )

5
TUBE TYPE SELECTION FOR TUBE-1
6
(Also refer to switch position 3243SW3-5)
7

3243SW2-x FUNCTION

2 FLUORO HOLD-OVER TIME

5
TUBE TYPE SELECTION FOR TUBE-2
6
(Also refer to switch position 3243SW4-5)
7

DR-1004R11 1
HF Series Generators
LV-DRAC

3243SW3-x FUNCTION

1 LOW SPEED ROTATION BRAKE

2 NOT USED*

3 SPOT FILM HIGH SPEED START

4 NOT USED*

ON = WHEN THE TUBE CONFIGURED AS TUBE-1

IS LISTED ON TUBE TABLE-1
5
OFF = WHEN THE TUBE CONFIGURED AS TUBE-1
IS LISTED ON TUBE TABLE-2

7 NOT USED*

* Note: Set switches not used in “ON” position.

3243SW4-x FUNCTION

2
SPOT FILM HOLD TIME
3

ON = WHEN THE TUBE CONFIGURED AS TUBE-2

IS LISTED ON TUBE TABLE-1
5
OFF = WHEN THE TUBE CONFIGURED AS TUBE-2
IS LISTED ON TUBE TABLE-2

ON = SELF RUNNING ENABLED (Refer to section 1.2)

6
OFF = SELF RUNNING DISABLED (Refer to section 1.2)

7 PROTECTIONS -- ERRORS

8 DC BRAKE

* Note: Set switches not used in “ON” position.

Note . Set dip switches in accordance with the following tables.

2 DR-1004R11
 HF Series Generators
LV-DRAC

TUBE SELECTION -- TUBE TABLE-1

(Switch 3243SW3-5 = ON for Tube-1 ) (Switch 3243SW4-5 = ON for Tube-2)

3243SW1-x (TUBE-1) 3243SW2-x (TUBE-2)

P
Pos TUBE FAMILY
(Stator - ∅ Anode) 4 5 6 7 8 4 5 6 7 8

0 GE MAXIRAY 75 ON ON ON ON ON ON ON ON ON ON

1 GE MAXIRAY 100 OFF ON ON ON ON OFF ON ON ON ON

2 VARIAN G-1582 ON OFF ON ON ON ON OFF ON ON ON

VARIAN RAD-XX or EUREKA RAD-XX (3” Anode,

Emerald or Diamond Housing, R Stator (20--50 ohm), 300 KHU)
3 OFF OFF ON ON ON OFF OFF ON ON ON
VARIAN A132 (3” Anode, 300 KHU)

VARIAN RAD-XX or EUREKA RAD-XX (4” Anode,

Sapphire Housing, R Stator (16--50 ohm or 20--50 ohm), 400 KHU)

VARIAN RAD-56 (4” Anode, Sapphire Housing,

R Stator (20--50 ohm), 400 KHU)
4 ON ON OFF ON ON ON ON OFF ON ON
VARIAN A256 / A282 / A292 (4” Anode, B130 or B150 Housing,
R Stator (16--50 ohm or 20--50 ohm), 400 KHU)

TOSHIBA 7254X / 7255X / 7823 (4” Anode,

XS-RB Stator (20--38 ohm), 400 KHU)

5 CGR STATORIX M50 (MAMMO) OFF ON OFF ON ON OFF ON OFF ON ON

SIEMENS 100 L BIANGULIX

6 ON OFF OFF ON ON ON OFF OFF ON ON
SIEMENS 100 L OPTILIX

7 PHILIPS SUPEROTALIX OFF OFF OFF ON ON OFF OFF OFF ON ON

8 DUNLEE PX-1302 ON ON ON OFF ON ON ON ON OFF ON

9 CGR STATORIX 260 / RSN 742 / MSN 740 OFF ON ON OFF ON OFF ON ON OFF ON

CGR STATORIX 550 / RSN 722 / MSN 722

10 ON OFF ON OFF ON ON OFF ON OFF ON
IAE RTC 600

11 SIEMENS 100 G OFF OFF ON OFF ON OFF OFF ON OFF ON

12 SIEMENS RH 150/100 ON ON OFF OFF ON ON ON OFF OFF ON

13 COMET DO-10 (4” Anode) OFF ON OFF OFF ON OFF ON OFF OFF ON

14 COMET DO-9 (4” Anode) ON OFF OFF OFF ON ON OFF OFF OFF ON

15 CGR STATORIX 240 OFF OFF OFF OFF ON OFF OFF OFF OFF ON

16 PICKER PX-307 ON ON ON ON OFF ON ON ON ON OFF

17 HANGZHOU XD-52-30, 50/150 OFF ON ON ON OFF OFF ON ON ON OFF

18 DUNLEE PX-1312 ON OFF ON ON OFF ON OFF ON ON OFF

19 DUNLEE PX-1456 / PX-1436 / PX-1400 (Q Stator) OFF OFF ON ON OFF OFF OFF ON ON OFF

20 COMET DX-1000 ON ON OFF ON OFF ON ON OFF ON OFF

21 COMET DX-81 / COMET XSTAR-14 OFF ON OFF ON OFF OFF ON OFF ON OFF

22 PHILIPS ROTALIX 350/351 ON OFF OFF ON OFF ON OFF OFF ON OFF

23 COMET MOS-50 (MAMMO) OFF OFF OFF ON OFF OFF OFF OFF ON OFF

24 VARIAN B110 / B112 / B115 Housing ON ON ON OFF OFF ON ON ON OFF OFF

25 VARIAN B160 / B165 Housing OFF ON ON OFF OFF OFF ON ON OFF OFF

26 TOSHIBA E7252X (XS-AL Stator) ON OFF ON OFF OFF ON OFF ON OFF OFF

27 COMET DX 700 HS OFF OFF ON OFF OFF OFF OFF ON OFF OFF

28 VARIAN A192 / A196 / A197 (with B130 Housing) ON ON OFF OFF OFF ON ON OFF OFF OFF

29 VARIAN G 1592 OFF ON OFF OFF OFF OFF ON OFF OFF OFF

30 PICKER PX400P + PX457P ON OFF OFF OFF OFF ON OFF OFF OFF OFF

31 JUGORENDGEN RX 150/30 - 50 OFF OFF OFF OFF OFF OFF OFF OFF OFF OFF

DR-1004R11 3
HF Series Generators
LV-DRAC

TUBE SELECTION -- TUBE TABLE-2

(Switch 3243SW3-5 = OFF for Tube-1 ) (Switch 3243SW4-5 = OFF for Tube-2)

3243SW1-x (TUBE-1) 3243SW2-x (TUBE-2)

Pos TUBE FAMILY
(Stator - ∅ Anode) 4 5 6 7 8 4 5 6 7 8

0 VARIAN GS-20711 (B220H Housing, R Stator) ON ON ON ON ON ON ON ON ON ON

1 SIEMENS 100 L--W OFF ON ON ON ON OFF ON ON ON ON

2 SIEMENS SV 125/15/82 ON OFF ON ON ON ON OFF ON ON ON

3 IAE RTM90 (C55 Housing) / IAE RTM92 (C52 / C352 Housing) OFF OFF ON ON ON OFF OFF ON ON ON

4 IAE RTM101HS / IAE RTM102HS (C100 Housing) ON ON OFF ON ON ON ON OFF ON ON

5 DUNLEE DA 1036 -- DU 404 OFF ON OFF ON ON OFF ON OFF ON ON

6 DUNLEE DA 1094 -- DU 694 ON OFF OFF ON ON ON OFF OFF ON ON

7 DUNLEE DR 1817 / 1825 (High Impedance Stator) OFF OFF OFF ON ON OFF OFF OFF ON ON

8 CGR STATORIX 240 / 260; MSN 740, MSN 742 ON ON ON OFF ON ON ON ON OFF ON

9 IAE RTC 700 HS (C52S Housing) OFF ON ON OFF ON OFF ON ON OFF ON

10 VARIAN GS 30711 ON OFF ON OFF ON ON OFF ON OFF ON

11 VARIAN G292 / G294 / G256 / G297 (B130 Housing) OFF OFF ON OFF ON OFF OFF ON OFF ON

12 IAE RTM101HS / RTM102HS (C52S Housing) ON ON OFF OFF ON ON ON OFF OFF ON

13 IAE RTC1000HS (C52S Housing) OFF ON OFF OFF ON OFF ON OFF OFF ON

14 TOSHIBA ROTANODE E7100X ON OFF OFF OFF ON ON OFF OFF OFF ON

15 DUNLEE DA 1083 / PX 1483 (DU 404 / DA10 Housing, C Stator) OFF OFF OFF OFF ON OFF OFF OFF OFF ON

16 VARIAN A277 / A278 (B130H and B150H Housing, R Stator) ON ON ON ON OFF ON ON ON ON OFF

17 VARIAN G1092 (B160 / B165 Housing, R Stator) OFF ON ON ON OFF OFF ON ON ON OFF

18 DUNLEE PX1473Q -- DU 604 ON OFF ON ON OFF ON OFF ON ON OFF

19 TOSHIBA E7260DX OFF OFF ON ON OFF OFF OFF ON ON OFF

20 VARIAN HE100 (B180 / B185 Housing, R Stator) ON ON OFF ON OFF ON ON OFF ON OFF

21 IAE RTC 137 (CT 180 Housing) OFF ON OFF ON OFF OFF ON OFF ON OFF

22 VARIAN A102 (B100 Housing) ON OFF OFF ON OFF ON OFF OFF ON OFF

IAE X40 (C352 Housing (only Low Speed))

23 OFF OFF OFF ON OFF OFF OFF OFF ON OFF
IAE RTM78HS (C352 Housing)

VARIAN RAD-92 / RAD-94 (4” Anode, Sapphire Housing,

R Stator (20--50 ohm), 600 KHU)
24 ON ON ON OFF OFF ON ON ON OFF OFF
IAE RTC600 HS (C100 Housing 4”, 102 mm, 600 KHU,
Stator 20--40 ohm)

25 TOSHIBA ROTANODE E7867X / E7869X OFF ON ON OFF OFF OFF ON ON OFF OFF

26 TOSHIBA ROTANODE E7239X / E7240X / E7242X / E7865X ON OFF ON OFF OFF ON OFF ON OFF OFF

27 TOSHIBA ROTANODE E7864X OFF OFF ON OFF OFF OFF OFF ON OFF OFF

28 SIEMENS RAY-14_1 (SV150/33/78S Insert) ON ON OFF OFF OFF ON ON OFF OFF OFF

TOSHIBA ROTANODE E7252X (XS-R Stator)

29 OFF ON OFF OFF OFF OFF ON OFF OFF OFF
TOSHIBA ROTANODE E7886X (Stator (27--58 ohm)

30 ATX 10WX--692 / 1463 (ATI692) (Stator C 47/60, 4”; 600 KHU) ON OFF OFF OFF OFF ON OFF OFF OFF OFF

31 PHILIPS SRM 1551 ROT500 OFF OFF OFF OFF OFF OFF OFF OFF OFF OFF

4 DR-1004R11
 HF Series Generators
LV-DRAC

MINIMUM TIME FOR READY (DELAY)

3243SW1-x
MINIMUM TIME
(SECONDS) 1 2 3

0* ON ON ON

0.6 OFF ON ON

0.8 ON OFF ON

1.0 OFF OFF ON

1.2 ON ON OFF

1.5 OFF ON OFF

2.0 ON OFF OFF

3.0 OFF OFF OFF

* Note: It is recommended to set these switches at “0 seconds”.

FLUORO HOLD TIME

3243SW2-x
FLUORO HOLD TIME
(SECONDS) 1 2 3

0 ON ON ON

10 OFF ON ON

20 ON OFF ON

30 OFF OFF ON

40 ON ON OFF

60 OFF ON OFF

90 ON OFF OFF

120 OFF OFF OFF

DR-1004R11 5
HF Series Generators
LV-DRAC

SPOT FILM HOLD TIME

3243SW4-x
SPOT FILM
HOLD TIME 1 2 3 4

0 ON ON ON ON

5 OFF ON ON ON

10 ON OFF ON ON

15 OFF OFF ON ON
SECONDS
20 ON ON OFF ON

30 OFF ON OFF ON

45 ON OFF OFF ON

60 OFF OFF OFF ON

2 ON ON ON OFF

5 OFF ON ON OFF

10 ON OFF ON OFF

15 OFF OFF ON OFF

MINUTES
20 ON ON OFF OFF

25 OFF ON OFF OFF

30 ON OFF OFF OFF

40 OFF OFF OFF OFF

SPOT FILM HIGH SPEED START

SPOT FILM START MODE 3243SW3-3

SPOT FILM ALWAYS STARTS IN HIGH SPEED (10000 RPM) ON

SPOT FILM STARTS AT REQUIRED SPEED OFF

6 DR-1004R11
 HF Series Generators
LV-DRAC

LOW SPEED ROTATION BRAKE

LOW SPEED ROTATION BRAKE MODE (3300 RPM TO 0 RPM) 3243SW3-1

INHIBITED ON

ACTIVATED OFF

DC BRAKE (FOR LOW AND HIGH SPEED)

DC BRAKE 3243SW4-8

ACTIVATED ON

INHIBITED OFF

PROTECTIONS -- ERRORS

PROTECTIONS -- ERRORS 3243SW4-7

INHIBITED
ON
(LED DL1 on the Control DRAC Board is always illuminated)

ACTIVATED (Normal Operation mode)

(LED DL1 on the Control DRAC Board is non-illuminated OFF
indicating that the DRAC is working properly).

Note: The Error Codes are shown on the Console Display preceded by the letter “E”
(a.e. E51) (For Error Codes refer to the Troubleshooting document).

WHEN SWITCH 3243SW4-7 IS IN THE “ON” POSITION, THE

ERROR PROTECTIONS OF THE LV-DRAC ARE INHIBITED.

DR-1004R11 7
HF Series Generators
LV-DRAC

1.1 LV-DRAC STATUS DIAGRAM

CHANGE
OF TUBE

ACCELERATION STAND-BY ACCELERATION

UP TO 3300 RPM UP TO 10000 RPM

RUNNING RUNNING
AT 3300 RPM AT 10000 RPM

BRAKING SELF-RUNNING MODE BRAKING

FROM 3300 RPM FROM 10000 RPM

1.2 SELF-RUNNING MODE

The continuous starting and braking of the anode produces an overheating in

the X-ray Tube Stator (a.e. during calibration procedure). The “Self-running
mode” avoids this overheating.

In the “Self-running mode” (switch 3243SW4-6 in the “ON” position), the anode
remains running for approximately 1 minute when rotates at 3300 rpm or
10000 rpm.

The LV-DRAC enters in the “Self-running mode” when “Preparation” is selected

three consecutive times only from the Console buttons or Handswitch, and
the time between two of the consecutive accelerations is shorter than
30 seconds (refer to illustration below).

PREPARATION SIGNALS
t < 30 s t < 30 s t < 30 s t > 30 s t < 30 s t < 30 s t < tsr

ANODE ROTATION

tsr tsr
Self-running mode Self-running mode

tsr (time for self-running mode) = approx. 1 minute at 3300 rpm or 10000 rpm.

8 DR-1004R11
 HF Series Generators
LV-DRAC

SECTION 2 SCHEMATICS

Sch. No. Scheme

LV-DRAC MODULE BLOCK DIAGRAM

A3243--04 CONTROL DRAC PCB

A3240--05 INTERFACE DRAC PCB

A3109--01 CLAMPING PCB

DR-1004R11 9
HF Series Generators
LV-DRAC

This page intentionally left blank.

10 DR-1004R11
 LV-DRAC MODULE

INTERFACE
CONTROL PTR1
HV INVERTER MAIN / AUX
MODULE DRAC PCB 3PH - IGBT INVERTERS
U2 TRANSFORMERS
(M) MAIN
F3
U3
INPUT
RECTIFIER Filter Ferrites M C A (A) AUX
MAINS DC BUS
PCB
(C) COMM
F4

LV DC
240 VAC SW Power Acc Run Com
Supply
J1

U16 U11 A -- D Contactors

Ribbon Cable

OUTPUT CONTROL LOGIC CURRENT

LIMIT
CONTROL Acceleration /
Running Voltage
Control
Drac
Power U15 (ADC)
Supply
AC / DC CONVERTERS
J3 I AUX U4B, C & D
DC Brake
D
I MAIN
U1C, D & A
OC A
DRIVER I COMMON U12A, B & U1B Tube Selection

OP1-- OP2
OUTPUT OPTO
COMMANDS COUPLERS U17
Common
μC Stator
Main / Aux Tube 1

RL2
READY
SW1 to SW4 CONTROL DRAC PCB Common
Stator
SYSTEM Main / Aux Tube 2
CONFIGURATION
ERROR SWITCHES
DRAC DL2
Open
Collector
Serial Link Driver

LV-DRAC Module Block Diagram

 A B C D E

PTR1
VS1 D19 D20
+5 VDC +5 VDC C15 Q12 BC640
AR1 PD ( 0.......7 ) 3
8x10K C29 100nF TP9
100nF D40 D42 R117 D45 1N5819 BAT49
R29 33.2
BAT49 BAT49 1K D44 1N4148

6
U9 TC4426 TF5 6 1N4148 Q5

20
1
SW1 U13 HCT244 2 7

GND VDD
PD7 C11 INA OUTA
8 9 2 1Y1 18 5

VCC
1A1 PD6 +5 VDC C65 R116 R30 BC640 D21
7 10 4 1A2 1Y2 16
6 11 6 PD5
1A3 1Y3 14 PD4 AR6
C12 4 INB OUTB 5 3 4
1K 2K21 BAT49
5 12 8 1A4 1Y4 12
4 13 11 PD3 8x4K7 PD0 220nF D41 D43
2Y1 9
4 4
2A1 PD2 PD1

3
3 14 13 2A2 2Y2 7 4
2 15 15 PD1 PD2 BAT49 BAT49 C59
2A3 2Y3 5 PD0 PD3 10uF
1 16 17 2A4 2Y4 3 PD4
1 PD5 VS2 D10 D11

GND
1G PD6 C12 Q15 BC640
CS3 19 2G 9
PD7 100nF TP6
D58 D60 R123 D63 1N5819 BAT49

10
R23 33.2
BAT49 BAT49 1K D62 1N4148

6
U6 TC4426 1 TF2 6 1N4148 Q2
+5 VDC 2 7

GND VDD
C21 INA OUTA
C47 5
10uF C68 R122 R24 BC640 D12
+5 VDC +5 VDC 4 5 3 4
AR2 C22 INB OUTB
8x10K C30 1K 2K21 BAT49
100nF +5 VDC 220nF D59 D61
U17

3
40
87C54 BAT49 BAT49 C62 10
PD0 10uF
20 31 39

VCC
SW2 U14 HCT244 C43 EA/VPP P0.0(AD0) PD1
P0.1(AD1) 38
8 9 2 18 PD7 33pF 37 PD2 VS1 D22 D23
VCC
1A1 1Y1 PD6 P0.2(AD2) PD3 C16 Q11 BC640
7 10 4 1A2 1Y2 16 19 X1 P0.3(AD3) 36 1
6 11 6 14 PD5 35 PD4 100nF TP10
1A3 1Y3 PD4 P0.4(AD4) PD5 D34 D36 R115 D39 1N5819 BAT49
5 12 8 1A4 1Y4 12 P0.5(AD5) 34
4 13 11 9 PD3 X1 33 PD6 R31 33.2
2A1 2Y1 PD2 P0.6(AD6) PD7 BAT49 BAT49 1K D38 1N4148
3 14 13 2A2 2Y2 7 P0.7(AD7) 32

6
2 15 15 5 PD1 C44 12MHz U10 TC4426 1 TF6 6 1N4148 Q6
3
2A3 2Y3 PD0 33pF 3
1 16 17 3 2 7

GND VDD
2A4 2Y4 P11 INA OUTA
18 X2 5
1 C64 R114 R32 BC640 D24
GND

1G
CS2 19 2G P12 4 INB OUTB 5 3 4
1K 2K21 BAT49
9 21 220nF D35 D37
RSTuP PWM
10

RESET P2.0(A8)

3
P2.1(A9) 22 PWMC 2
29 23 BAT49 BAT49 C58
PSEN P2.2(A10) C1
24 10uF
P2.3(A11) C2
ALE 30 ALE/PROG P2.4(A12) 25 MODP1
26 VS2 D13 D14
P2.5(A13) MODP2
27 C13 Q14 BC640
P2.6(A14) MODA1 7
+5 VDC +5 VDC +5 VDC 28 100nF TP7
AR3 P2.7(A15) MODA2
8x10K C39 R86 D52 D54 R121 D57 1N5819 BAT49
100nF 10K2 R25 33.2
BAT49 BAT49 1K D56 1N4148

6
U7 TC4426 1 TF3 6 1N4148 Q3
20

2 7

GND VDD
P21 INA OUTA
SW3 U18 HCT244 5
8 9 2 PD7 C67 R120 R26 BC640 D15
1Y1 18 1 10
VCC

1A1 PD6 A0 P1.0(T2) P3.0(RXD) T2

7 10 4 1A2 1Y2 16 A1 2 P1.1(T2EX) P3.1(TXD) 11 T3 P22 4 INB OUTB 5 3 4
6 11 6 PD5 1K 2K21 BAT49
1A3 1Y3 14 PD4 A2 3 P1.2 P3.2(INT0) 12 ST
220nF D53 D55
5 12 8 1A4 1Y4 12 RAW 4 P1.3 P3.3(INT1) 13 HS
PD3

3
4 13 11 2A1 2Y1 9 ENuP 5 P1.4 P3.4(T0) 14 FL 8
3 14 13 PD2 BAT49 BAT49 C61
2A2 2Y2 7 PD1 AUTO 6 P1.5 P3.5(T1) 15 SF
10uF
2 15 15 2Y3 5 7 16
GND

2A3 PD0 RD P1.6 P3.6(WR) SPARE1

1 16 17 2A4 2Y4 3 WR 8 P1.7 P3.7(RD) 17 SPARE2
VS1 D16 D17
1 C14 Q13 BC640
GND

20

2 1G 100nF TP8 5 2
CS1 19 2G D46 D48 R119 D51 1N5819 BAT49
R27 33.2
10

BAT49 BAT49 1K D50 1N4148

6
U8 TC4426 1 TF4 6 1N4148 Q4
2 7

GND VDD
A11 INA OUTA
5
C66 R118 R28 BC640 D18
A12 4 INB OUTB 5 3 4
1K 2K21 BAT49
220nF D47 D49
+5 VDC +5 VDC

3
AR4 8x10K C40 BAT49 BAT49 C60 6
100nF 10uF
+15 VDC VS1 +15 VDC VS2
Q10 Q9 VS2 D7 D8
2N4403 2N4403 C11 Q16 BC640
20

SW4 U19 HCT244 100nF TP5 11

8 9 2 PD7 D64 D66 R125 D69 1N5819 BAT49
1Y1 18
VCC

1A1 PD6 R21 33.2

7 10 4 1A2 1Y2 16
6 11 6 PD5 R113 R2 BAT49 BAT49 1K D68 1N4148
1A3 1Y3 14

6
5 12 8 PD4 2K21 2K21 U5 TC4426 TF1 6 1N4148 Q1
1A4 1Y4 12 PD3
1
4 13 11 2Y1 9 2 7

GND VDD
2A1 PD2 A21 INA OUTA
3 14 13 2A2 2Y2 7 5
2 15 15 PD1 C69 R124 R22 BC640 D9
2A3 2Y3 5 PD0
1 16 17 2A4 2Y4 3 A22 4 INB OUTB 5 3 4
R111 R112 R68 R17 1K 2K21 BAT49
1 220nF D65 D67
GND

1G 475 1K5 475 1K5

3

1 CS0 19 2G 12 1
BAT49 BAT49 C63
10uF
10

DZ3 DZ2
12V 12V NAME DATE SHEET / OF
DRAWING F. Díaz 12/06/08
A3243-04
1/3
REVISED A. Díaz 12/06/08 E D REV

E NC 09/204 F. Díaz 14/07/09

D NC 09/151 F. Díaz 03/05/09 SEDECAL CONTROL DRAC
REV DESCRIPTION ISSUED BY DATE
A B C D E
 A B C D E

PTR1 VBUS (4V<>724 VDC)

PD ( 0.......7 )
TP18
R63
604K

P+

N-
V
+15 VDC

R66 +5 VDC
22K1 +5 VDC
4x1N4148 C37 10uF
D28 D27
C18 R34 R35 R36 R75 R65 D29
J1 470nF 1000V 1M 1M 1M 1M 604K 1N4148 U15

20
4 4
COM U12D D31 R74 ADC0844
3 U12C R67 LF347 1N4148 1K5 PD0
13 DB0 17

VCC
9 LF347 604K 14 3 PD1
CH1 DB1 16 PD2
8 12 DB2 15
SHL R40 R39 R38 R76 R64 10 R73 4 PD3
2 1M 1M 1M 1M 604K 10K2 CH2 DB3 14 PD4
R37 R33 DB4 13 PD5
5 CH3 DB5 12
150K-2w 150K-2w C31 PD6
100nF C36 DB6 11 PD7
6 DB7 9
J2 R72 100nF CH4
V+ D26 D25 8 2
2 VREF CS CS4
DL7 DL8 22K1 +5 VDC 1
RD RD
HLMP1700 HLMP1700 7 19

GND
AGND WR WR
INTR 18
V- C19 C17
1 -15 VDC C27

10
100uF 450V 100uF 450V 100nF

+15 VDC
C5 I.PRINC
PTR1 100nF TP17 TP36
R88
221K R60
U 1V<>8.26A 221K
U2 CSNH151 TP1
3 R8 R7 R10 R4 +5 VDC 3
V+

1-7 12K1 12K1 12K1 12K1 +5 VDC

OP D1
D3 1N4148 D73
V-

J1 8-14 1N4148 U1A D32 R1 R61 1N4148 D72 U1B

U1C U1D R3 2 LF347 1N4148 1K5 1K5 1N4148 LF347 6
PRIN C4 R9 9 LF347 13 LF347 221K 1 7
1 100nF 8 14 3 5
100 10 12 R5 R62
10K2 10K2
D2
R6 1N4148 C1
-15 VDC 12K1 1uF C35 C25
100nF 100nF

+15 VDC
C6 I.AUX
PTR1 100nF TP16
R89
221K
W
U3 CSNH151 TP3
R12 R14 R15 R19 +5 VDC
V+

8-14 12K1 12K1 12K1 12K1

OP D6
D5 1N4148
V-

J1 1-7 1N4148 U4B D33 R18

2 2
U4D U4C R16 6 LF347 1N4148 1K5
AUX C7 R11 13 LF347 9 LF347 221K 7
4 100nF 14 8 5
100 12 10 R20
10K2
D4
R13 1N4148 C10
-15 VDC 12K1 1uF C34
100nF

R53 R55 R57 R58

12K1 12K1 12K1 12K1

R54 D70
P+
PTR1 12K1 1N4148
SKM 40GD 123D
U12A U12B R59
2 LF347 6 LF347 221K
1 7
C28 +15 VDC C3 +15 VDC C8 +15 VDC 3 5
100nF 100nF 100nF
I.PRINC LIMIT
D71
1 3 5 R56 1N4148
12K1 C24
I.AUX LIMIT
1uF
2 4 6
U12D U1B U4A
4

U V W LF347 LF347 LF347

1 1
2
1
3
7 9 11
NAME DATE SHEET / OF
11

11

11

DRAWING F. Díaz 12/06/08

A3243-04
8 10 12 2/3
C26 C2 C9 REVISED A. Díaz 12/06/08 E D REV
100nF 100nF 100nF
N-
E NC 09/204 F. Díaz 14/07/09
D NC 09/151 F. Díaz 03/05/09 SEDECAL CONTROL DRAC
-15 VDC -15 VDC -15 VDC
REV DESCRIPTION ISSUED BY DATE
A B C D E
 A B C D E

R50 VUNR +5 VDC +5 VDC

1K5 U11B +5 VDC AR5 8x4K7
RSTuP PD ( 0.......7 )
4 - LM339 C38 C45
I. PRINC
2 C57 DZ1 R71 100nF 100nF
Limit
C22 5 + R94 2K2 J4
100nF 13V 1K5 TP30 OP1A TPL621-4 SPARE2
+15 VDC 1nF 9
1
R90 R93

18

52
SPARE2 16
23K7 U11D R69 +5 VDC
10 - LM339 C41 15 2K2
13 1K5 1nF 12 20 PD0 2 SPARE2 RTN
R126 C32 PD1 10
11 + 21
Q8 22 PD2 R92 2K2
4 10K2 100nF 2N4401 D30 R83 48 PD3 TP27 OP1B TPL621-4 SPARE1 4
R127 1N4148 221K PD4 11
49 3
23K7 U11A R70 R82 50 PD5 14 R91
PD6 SPARE1
6 - LM339 10K2 51
1 1K 56 54 PD7 13 2K2
R45 C33 7 + 4 SPARE1 RTN
C46 12
5 C11
-15 VDC 10K2 100nF I.LIM R98 2K2
+5 VDC TP11 1uF 32 TP31 OP1C TPL621-4 SF
C12 13
U11C R52 R49 Q7 R51 5
R47 8 - LM339 2K21 1K 2N4403 221 44 12 R97
C21 SF
1K5 14 33
9 + 45 11 2K2
I. AUX C22
R48 C52 6 SF RTN
Limit C21 14
6 P11
NOTE: 4.5 V < >37 Amp. pick 221 10nF R96 2K2
1nF 7 TP28 OP1D TPL621-4 FL
for I. PRINC or I. AUX P12 15
7
24 8 10 R95
ENuP P21 FL
TP29 TP25 TP21 TP20 23 9 9 2K2
AUTO P22
J3 U16 8 16 FL RTN
+5 VDC TP14
N.U. 68 10 A11
TP24 TP26 TP22 TP23 A3607-01A R102 2K2
+5 VDC 53 11 TP32 OP2A TPL621-4 HS
1 ALE A12 17
1
+5 VDC 34 2 16 R101
2 PWM A21 HS
C51
+5 VDC 26 3 15 2K2
3 PWMC A22
3 470uF 2 HS RTN 3
18
+5 VDC 4 C1 17 30 CS4
R100 2K2
GND 19 29 TP33 OP2B TPL621-4 ST
5 C2 CS3 19
3
GND 47 28 14 R99
6 MODP1 CS2 ST
GND C50 59 27 13 2K2
7 MODP2 CS1
4 20 ST RTN
GND 470uF +15 VDC TP15 25 4
8 MODA1 CS0
R106 2K2
+15 VDC 46 TP34 OP2C TPL621-4 T3
9 MODA2 21
5
+15 VDC 55 12 R105
10 RAW T3
+15 VDC 14 11 2K2
11 A0
6 22 T3 RTN
+15 VDC TP37 +5 VDC
12 R104 2K2
-15 VDC TP35 OP2D TPL621-4 T2
13 23
7
-15 VDC 10 R103
14 T2
-15 VDC TP2 TP4 TP12 TP13 TP19 R109 R108 R107 R110
C49 9 2K2
2K21 2K21 2K21 2K21 8 T2 RTN
470uF 24
+15 VDC

2 6 +15 VDC 2
C55 C54 C53 C56
+15 VDC
1nF 1nF 1nF 1nF DL3 R43 3K3
VUNR +15 VDC RDY1
4
3 x HLMP1700 15 +5 VDC HLMP1700 RL2
A1
VUNR 15 A2 16 7 RDY1 RTN
ERROR
VUNR DL6 DL5 DL4 C48 22uF DL1
16 HLMP1700 R44 82 PRME15002
5 RDY1 OUT
R85 R81 R79 U20
10

PRECH IF R87 ULN2803 R46 10

17 22 3K3 3K3 3K3 R77
VCC

PRECH IF 18 11 Q8 I8 8 ERROR CODE 40 8

12 7 RDY1 39 750
Q7 I7 DISCH +5 VDC
13 Q6 I6 6 57
+5 VDC 14 5 PRECH 38 DL2 R41 750
Q5 I5 BRAKE
+5 VDC 19 15 Q4 I4 4 36 37 3
16 3 T3 43
Q3 I3 T2 HLMP1700
+5 VDC 20 17 Q2 I2 2 42
18 1 T1 41 R42 10
GND

Q1 I1
2 ERROR DRAC
+15 VDC C23
35

T3 IF R84 100nF
1

21 22
9

T3 IF 22 1 GND
1 1
3

U11A
T2 IF R80 LM339
23 22
+
T2 IF 24 - NAME DATE SHEET / OF
DRAWING F. Díaz 12/06/08
A3243-04
3/3
12

C20 REVISED A. Díaz 12/06/08 E D REV

T1 IF R78 100nF
25 22
T1 IF 26
E NC 09/204 F. Díaz 14/07/09
T1 IF: T1 to T2 Commutation
D NC 09/151 F. Díaz 03/05/09 SEDECAL CONTROL DRAC
T2 IF: Not Used -15 VDC
T3 IF: Break Control REV DESCRIPTION ISSUED BY DATE
A B C D E
 A B C D E

V UNR +15 VDC +5 VDC

CR5 CR6 J1
1N4007 1N4007 +5 VDC
1
+5 VDC
2 +5 VDC

REG1 LM7815 REG2 LM7805 +5 VDC

3
VIN VOUT VIN VOUT

GND

GND
4
4 +5 VDC 4

CR1 CR2

1N4007 1N4007
J3 F1 GND
T 0.5 A
TR1 5
220 VAC SW C1 C3 C4
1 2200uF 10uF 10uF
6 GND
35V 35V 35V

15 VAC GND
7

220 VAC GND

8

15 VAC
F2 +15 VDC
T 0.5 A C2 C5 9
0 VAC 2200uF 10uF +15 VDC
2 35V 35V
10 +15 VDC

CR3 CR4 +15 VDC

R1 11
150K 1N4007 1N4007
2W DS1 +15 VDC

GND
3
12 3

HLMP1700
R2 VIN VOUT
150K REG3 LM7915
J2 2W
13 -15 VDC
F3
T 15 A FILT1
-DC IN 1 5 9 14 -15 VDC
CR7
1N4007
6 10 -15 VDC
CAR-DRAC BUS
V UNR
F4 -15 VDC V UNR 15
T 15 A 2 12
+DC IN V UNR

14
2 3 13 16
1

8
17

18
GND 3 +5 VDC +5 VDC
19

20 +5 VDC
2 2

+DC OUT 4 21 T3 IF

22 T3 IF
-DC OUT 5
T2 IF T1 IF: T1 to T2 Commutation
23 T2 IF: Not Used
T1 IF: Break Control
24 T2 IF
J5
25 T1 IF
1

26 T1 IF

CR9 CR8 CR12 CR13 CR14

STTH1212D STTH1212D
1N4007 1N4007 1N4007
J4
2
1 K1
C6
220nF
VR1 KT2
1.5KE440CA 2

1 1
3 3 K3
PCB: 3240-05D

G NC 09/301 F. Díaz 16/11/09 NAME DATE SHEET / OF

CR11 CR10
STTH1212D STTH1212D F NC 09/178 F. Díaz 09/06/09 DRAWING F. GARCIA 27-09-97 A3240-05
1/1
E CN 01/075 F. GARCIA 03-05-01 REVISED A. DIAZ 27-09-97 H G F E D C B A REV

C, D CN 98/090, 99/94 F. GARCIA 15-02-00

4

H NC 10/252 F. Díaz 28/05/10 SEDECAL INTERFACE DRAC-HF

REV DESCRIPTION ISSUED BY DATE
A B C D E
 F E D C B A

4 4

R1
680 ALL DIODES CL03--15
15w
IN--1

CR1 CR2 CR3 CR4 CR5 CR6

3 3
C1 C2
R2 R3
10 nF 10 nF
150K 150K
12.5KV 12.5KV
15w 15w

IN--2

2 2

1
NAME DATE SHEET / OF
DRAWING F. GARCIA 12/01/99
DWG:
A3109--01
1/1
REVISED A. DIAZ 16/03/99 REV

SEDECAL
CLAMPING
INNERSCAN
F E D REV DESCRIPTION ISSUED BY DATE