PERFECTCARE COMPACT ESSENTIAL

STEAM GENERATOR

GC6800 GC6801 GC6802 GC6804 GC6808

GC6810 GC6819 GC6820 GC6822 GC6830
GC6833 RI6833 V13 GC6815 V13 GC6840 V13 GC6842

Published by Philips Consumer Lifestyle Page 1 of 38 For internal use only

Document No. : CSW-07-081-17169
 Contents
Page

1. Important Repair Instructions 3

2. Product Information
- Product Matrix 6
- Functions/ Features Information 10
- Wiring Diagram 11

3. Troubleshooting 13

4. Disassembly and Reassembly Instructions 15

5. Service Lists 18

6. Revision History 36

Published by Philips Consumer Lifestyle Page 2 of 38 For internal use only

Document No. : CSW-07-081-17169
Important Repair Instructions
1. Only skilled personnel should carry out the repair.
2. Verification test to carry out as follows, to determine the problem:
a. Ensure product are properly assembled
b. Power on
c. Water Tank to be filled up to Maximum level
3. Refer to Trouble shooting guide for part repair/replacement.
4. After repaired, the appliance must function properly, following test to be carried out:
a. POWER-ON CHECK
Powered-ON with socket equipped with Residual Current Circuit Breaker (RCCB) or Earth Leakage Circuit
Breaker (ELCB) to ensure no electrical hazard risk to end consumer.

b. Soleplate temperature
Check the soleplate temperature at maximum setting within IEC requirment.
Measure the temperature of the Soleplate after the iron has reached steady state i.e connected to the mains
for at least 15 minutes. The table below shows the temperature requirement.

Soleplate temperature (Deg C)

Minimum Maximum
101 Deg C 145 Deg C

c. Water leakage
Check that there is no water leakage from any part of product during operation.

d. Functionality
Check the functionality of the product such as:
- Steaming
- PCBA (Refer to point 6).
- Buttons: no sluggish, no jammed and loosennes
- Filling Door: able to open freely and close properly (with click sound)

e. Loose part
Check that there are no loose parts such as extra screws in the product that can cause short circuit or product
malfunction.

Published by Philips Consumer Lifestyle Page 3 of 38 For internal use only

Document No. : CSW-07-081-17169
Important Repair Instructions (Continue)
5. Self-Check mode
Self-Check mode is NOT an exhaustive dianosis, but a quick preliminary check on all the hardware function.

5.1 The following to be carried out before Self-Check mode:

i) Power meter should be in-placed to monitor system power.
ii) Minimum water level in the water tank
iii)Make sure Soleplate is <100°C

5.2 Reset product to Factory Mode Test (FMT) Flow

Published by Philips Consumer Lifestyle Page 4 of 38 For internal use only

Document No. : CSW-07-081-17169
Important Repair Instructions (Continue)
5.3 Perform Self Check Mode Process Flow Chart

Published by Philips Consumer Lifestyle Page 5 of 38 For internal use only

Document No. : CSW-07-081-17169
Product Information
Product Matrix

CTN GC6800 GC6801 GC6802 GC6804

Colour Marina Blue Marina Blue Purple Marina Blue
Optimal TEMP YES YES YES YES
Power (W) 2400 2400 2400 2400
Max pressure (bar) 5.5 5.5 5.5 5.5
Steam rate up to (g/min) 110 110 110 110
Steam boost up to (g) 200 210 220 230
Tank capacity (L) 1.3 1.3 1.3 1.3
Detachable water tank NO NO NO NO
Anti-Calc Smart Calc Clean Smart Calc Clean Smart Calc Clean Smart Calc Clean
Calc Clean reminder Sound & Light Sound & Light Sound & Light Sound & Light
Soleplate SteamGlide SteamGlide SteamGlide SteamGlide
Auto shut-off NO NO NO NO
Safety carry Lock NO NO NO NO
Turbo NO NO NO NO
Power cord material PVC PVC PVC PVC
Accessories Calc Clean Container Calc Clean Container Calc Clean Container Calc Clean Container
Cord length (m) 1.65 1.65 1.65 1.65
Hose length (m) 1.6 1.6 1.6 1.6
Heat up time (mins) 2 2 2 2

Published by Philips Consumer Lifestyle Page 6 of 38 For internal use only

Document No. : CSW-07-081-17169
 Product Information
Product Matrix

CTN GC6808 GC6810 GC6819 GC6820

Colour Aqua Blue/ Purple Aqua Mist / Aqua Mist /
Transdeep aqua Trans aqua blue Trans aqua blue
Optimal TEMP YES YES YES YES
Power (W) 2400 2400 2400 2400
Max pressure (bar) 5.5 5.5 5.5 5.5
Steam rate up to 110 110 110 110
(g/min)
Steam boost up to (g) 230 240 250 250
Tank capacity (L) 1.3 1.3 1.3 1.3
Detachable water tank NO NO NO NO
Anti-Calc Smart Calc Clean Smart Calc Clean Smart Calc Clean Smart Calc Clean
Calc Clean reminder Sound & Light Sound & Light Sound & Light Sound & Light
Soleplate SteamGlide SteamGlide SteamGlide SteamGlide
Auto shut-off NO NO NO NO
Safety carry Lock NO NO YES YES
Turbo NO NO NO NO
Power cord material PVC PVC PVC PVC
Accessories Calc Clean Container Calc Clean Container Calc Clean Container Calc Clean Container
Cord length (m) 1.65 1.65 1.65 1.65
Hose length (m) 1.6 1.6 1.6 1.6
Heat up time (mins) 2 2 2 2

Published by Philips Consumer Lifestyle Page 7 of 38 For internal use only

Document No. : CSW-07-081-17169
Product Information
Product Matrix

CTN GC6822 GC6830 GC6833 RI6833/32

Colour Viva Violet/ Aqua Mist/ Viva Violet/ Viva Violet/
Trans Aqua Purple Trans aqua blue Trans Aqua Purple Trans Aqua Purple
Optimal TEMP YES YES YES YES
Power (W) 2400 2400 2400 1800 / 127V
Max pressure (bar) 5.5 5.5 5.5 5
Steam rate up to (g/min) 110 110 110 85
Steam boost up to (g) 250 270 280 200
Tank capacity (L) 1.3 1.3 1.3 1.3
Detachable water tank NO NO NO NO
Anti-Calc Smart Calc Clean Smart Calc Clean Smart Calc Clean Smart Calc Clean
Calc Clean reminder Sound & Light Sound & Light Sound & Light Sound & Light
Soleplate SteamGlide SteamGlide Plus SteamGlide Plus SteamGlide Plus
Auto shut-off NO YES YES YES
Safety carry Lock YES YES YES YES
Turbo NO NO NO NO
Power cord material PVC PVC PVC PVC
Accessories Calc Clean Container Calc Clean Container Calc Clean Container Calc Clean Container
Cord length (m) 1.65 1.65 1.65 1.65
Hose length (m) 1.6 1.6 1.6 1.6
Heat up time (mins) 2 2 2 2

Published by Philips Consumer Lifestyle Page 8 of 38 For internal use only

Document No. : CSW-07-081-17169
Product Information
Product Matrix

CTN RI6833/34 V13 GC6815 V13 GC6840 V13GC6842

Colour Viva Violet/ Blue Pavone/ Blue Pavone/ Purple Magic/
Trans Aqua Purple Trans Deep Petrol Trans Deep Petrol Trans Aqua Purple
Optimal TEMP YES YES YES YES
Power (W) 2000 / 220V 2400 2400 GC6842/30: 2400
GC6842/36: 2400
GC6842/32: 1800/127V
GC6842/34: 2000/220V
Max pressure (bar) 5.5 6 6 6
Steam rate up to 110 120 120 GC6842/30: 120
(g/min) GC6842/36: 120
GC6842/32: 85
GC6842/34: 120
Steam boost up to (g) 280 360 360 GC6842/30: 360
GC6842/36: 360
GC6842/32: 200
GC6842/34: 360
Tank capacity (L) 1.3 1.3 1.3 1.3
Detachable water NO NO NO NO
tank
Anti-Calc Smart Calc Clean Smart Calc Clean Smart Calc Clean Smart Calc Clean
Calc Clean reminder Sound & Light Sound & Light Sound & Light Sound & Light
Soleplate SteamGlide Plus SteamGlide SteamGlide SteamGlide
Auto shut-off YES YES YES YES
Safety carry Lock YES YES YES YES
Turbo NO NO NO NO
Power cord material PVC PVC PVC PVC
Accessories Calc Clean Container Calc Clean Container Calc Clean Calc Clean Container
Cord length (m) 1.65 1.65 Container
1.65 1.65
Hose length (m) 1.6 1.6 1.6 1.6
Heat up time (mins) 2 2 2 2

Published by Philips Consumer Lifestyle Page 9 of 38 For internal use only

Document No. : CSW-07-081-17169
 Product Information
Functions/ Features Information
Product Information Scale Management
Technology  Descaling and cleaning: Smart Calc Clean
 For all ironable fabrics  Descaling reminder: Sound, Light
 No burn
 No temparature settings needed Storage
 Optimal TEMP Technology  Cord storage: Cord storage compartment
 ProVelocity steam engine  Hose storage: Hose storage compartment

Fast Crease Removal Accessories included

 Powerful steam for ultimate crease removal  Calc Clean Container
 SteamGlide Plus Soleplate for ultimate gliding
V13  Voltage: 220–240V (except RI6833/32 & GC6842/32)) Size & weight
 Product dimensions (WxHxL): 200 x 233 x 371 mm
Easy to use  Weight of Iron: 1.3 kg
 Safe on all ironable fabrics: Even delicates like silk  Weight of Iron & base: 2.8 kg
 Cord freedom (Swivel): 180 cord freedom
 Ready to Use: Light and Sound Indicator
 Refill Any Time During Use
 Soleplate Scratch Resistance: 4 stars
 Tap Water Suitable

Published by Philips Consumer Lifestyle Page 10 of 38 For internal use only

Document No. : CSW-07-081-17169
Product Information (Continue)
Wiring Diagram - Iron

Published by Philips Consumer Lifestyle Page 11 of 38 For internal use only

Document No. : CSW-07-081-17169
Product Information (Continue)
Wiring Diagram - Stand

Published by Philips Consumer Lifestyle Page 12 of 38 For internal use only

Document No. : CSW-07-081-17169
Troubleshooting
Problem Possible root cause Solution
Iron LED does not light up as Hose Cord Assy wiring Reconnect & retest
specified (refer to page 5) Iron LED Assy Change Iron LED Assy
Hose Cord Assy Change Hose Cord Assy
Power PCBA Change Power PCBA*
Other LEDs do not light up Power PCBA Change Power PCBA*
as specified (refer to page 5)
Zero-crossing detection Power PCBA Change Power PCBA*
circuit error (refer to page 5)
Iron temperature sensing Connection Reconnect & retest
circuit error (refer to page 5) Power PCBA Change Power PCBA*
Soleplate Assy Change Soleplate Assy
Iron heater power does not Iron is too hot Cool down and retest
meet as specified (refer to Soleplate Assy Change Soleplate Assy
page 5) PCBA Change Power PCBA*
No buzzer sound (refer to Connection Reconnect & retest
page 5) Power PCBA Change Power PCBA*
Motion sensor not functioning Handle PCB connection Reconnect & retest
correctly (refer to page 5) Handle PCB Change Handle PCB
Steam trigger pressed does Hose cord Assy connection Reconnect & retest
not detected (refer to page 5) Handle PCB Change Handle PCB
Hose Cord Assy Change Hose Cord Assy
E-Valve Change E-Valve
Trigger Change Trigger
Power PCBA Change Power PCBA*
Water leaking Connection for water path Reconnect & retest
Inlet Coupling Seal Change Inlet Coupling Seal
Inlet Coupling Assy Change Inlet Coupling Assy
Water Tank Assy Change Water Tank Assy
Soleplate Assy Change Soleplate Assy
Boiler Assy Change Boiler Assy & Inox Clamp
Lock jammed Stand Top Assy Change Stand Top Assy
Soleplate warp Change Soleplate Assy
No pumping Pump Assy Change Pump Assy & PRV Assy*
Trigger Change Trigger
Power PCBA Change Power PCBA*
Plastic molded part Inlay 2K Assy Change Inlay 2K Assy
damaged, broken, short Housing Prted Change Housing Prted
molding, cosmetic defect or Trigger Change Trigger
sharp edges Chassis Change Chassis
Cover Change Cover
Tray Assy Change Tray Assy
Stand Top Assy Change Stand Top Assy
Water Tank Assy Change Water Tank Assy
Stand Botttom Assy Change Stand Botttom Assy
Button Assy Change Button Assy
Iron Bottom Cap Change Iron Bottom Cap

Notes: * Refer to page 17 for Power PCBA/ Pump Assy replacement.

Published by Philips Consumer Lifestyle Page 13 of 38 For internal use only

Document No. : CSW-07-081-17169
Troubleshooting
LED Blinking Error Signal Interpretation

Published by Philips Consumer Lifestyle Page 14 of 38 For internal use only

Document No. : CSW-07-081-17169
Disassembly Instructions - Iron

Published by Philips Consumer Lifestyle Page 15 of 38 For internal use only

Document No. : CSW-07-081-17169
Disassembly Instructions - Stand

CLAMPING PLATE

CLAMPING PLATE

Published by Philips Consumer Lifestyle Page 16 of 38 For internal use only

Document No. : CSW-07-081-17169
Reassembly Instructions
Pump Assemble Functional Test and Pump-PCBA Calibration

Items Description
Classification of Test Functional Tests
Part/Module Pump Assy
Test Method General
Use pump flow rate tester to measure the total volume per pumping from the main outlet.
Check for any leakage between the pump and the components (PRV / braided rubber
hose).
Pump flow rate classification (for calibration of PCBA)
(1) Check pump flow rate. (supplier setup- Jiayin)
Pump Assy Flowrate Classification, Production Setup.
Test Condition: 230 V/50Hz ± 1% @ Ta = 20°C ± 5, 1 min ± 0.5% duration
Main Outlet
Category
Flow Rate (g)
Pump 1 198 - 220
Pump 2 221 - 242

(2) Match PCBA on final assembly by cutting appropriate jumper on PCBA.

PCBA Marking
Pump 1 (Low) Cut
Pump 2 (high) -

Pump marking location.

Test Setting See above.
Acceptance Criteria Pump Assy (Pump)
220 cc/min ± 10% cc/min

Published by Philips Consumer Lifestyle Page 17 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6800/20 GC6801/20 GC6802/30 GC6802/30

POS DESCRIPTION 889680020380 889680120380 889680230010 889680230290
ITALY ITALY WEU FRANCE
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902277981 423902277981 423902278641 423902278641
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278081 423902278081 423902278071 423902278071
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278221 423902278221 423902278191 423902278191
19A TRAY ASSY 423902278921 423902278931 423902278251 423902278251
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
22 FILLING DOOR MOLDED 423902278391 423902278391 423902278401 423902278401
23 WATER TANK ASSY 423902276611 423902276611 423902276621 423902276621
26 TUBE COVER MOLDED 423902278431 423902278431 423902278431 423902278431
27 STAND TOP MOLDED 423902278481 423902278481 423902278481 423902278481
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278541 423902278541 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269622 423902269622 423902269622
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277581 423902277581 423902277581
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 18 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6802/30 GC6804/20 GC6804/20 GC6804/20

POS DESCRIPTION 889680230600 889680420010 889680420040 889680420300
DUBAI WEU TURKEY RUSSIA
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902278641 423902277981 423902277981 423902277981
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278071 423902278081 423902278081 423902278081
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278191 423902278221 423902278221 423902278221
19A TRAY ASSY 423902278251 423902278261 423902278261 423902278261
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
22 FILLING DOOR MOLDED 423902278401 423902278391 423902278391 423902278391
23 WATER TANK ASSY 423902276621 423902276611 423902276611 423902276611
26 TUBE COVER MOLDED 423902278431 423902278431 423902278431 423902278431
27 STAND TOP MOLDED 423902278481 423902278481 423902278481 423902278481
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278541 423902278541 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269622 423902269622 423902269622
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277581 423902277581 423902277581
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 19 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6804/20 GC6804/20 GC6804/21 GC6804/26

POS DESCRIPTION 889680420380 889680420530 889680421160 889680426150
ITALY AUSTRALIA SWITZERLAND UK
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902277981 423902277981 423902277981 423902277981
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278081 423902278081 423902278081 423902278081
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278221 423902278221 423902278221 423902278221
19A TRAY ASSY 423902278261 423902278261 423902278261 423902278261
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
22 FILLING DOOR MOLDED 423902278391 423902278391 423902278391 423902278391
23 WATER TANK ASSY 423902276611 423902276611 423902276611 423902276611
26 TUBE COVER MOLDED 423902278431 423902278431 423902278431 423902278431
27 STAND TOP MOLDED 423902278481 423902278481 423902278481 423902278481
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278541 423902278541 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269622 423902269622 423902269622
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277861 423902277831 423902277591
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 20 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6804/26 GC6808/20 GC6808/20 GC6810/30

POS DESCRIPTION 889680426600 889680820010 889680820290 889681030290
DUBAI WEU FRANCE FRANCE
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902277981 423902277991 423902277991 423902278641
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278081 423902278091 423902278091 423902278071
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278221 423902278231 423902278231 423902278191
19A TRAY ASSY 423902278261 423902278261 423902278271 423902278281
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
22 FILLING DOOR MOLDED 423902278391 423902278381 423902278381 423902278401
23 WATER TANK ASSY 423902276611 423902276601 423902276601 423902276621
26 TUBE COVER MOLDED 423902278431 423902278431 423902278431 423902278431
27 STAND TOP MOLDED 423902278481 423902278481 423902278481 423902278481
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278541 423902278541 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269622 423902269622 423902269622
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277591 423902277581 423902277581 423902277581
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 21 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6819/20 GC6820/20 GC6820/20 GC6820/20

POS DESCRIPTION 889681920220 889682020010 889682020290 889682020300
GERMANY WEU FRANCE RUSSIA
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902278001 423902278001 423902278001 423902278001
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278061 423902278061 423902278061 423902278061
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278201 423902278201 423902278201 423902278201
19A TRAY ASSY 423902278301 423902278291 423902278301 423902278301
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
21 FRONT LOCK ASSY 423902278361 423902278361 423902278361 423902278361
22 FILLING DOOR MOLDED 423902278411 423902278411 423902278411 423902278411
23 WATER TANK ASSY 423902276671 423902276671 423902276671 423902276671
26 TUBE COVER MOLDED 423902278431 423902278431 423902278431 423902278431
27 STAND TOP MOLDED 423902278481 423902278481 423902278481 423902278481
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278541 423902278541 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269622 423902269622 423902269622
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277581 423902277581 423902277581
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 22 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6820/21 GC6822/30 GC6822/30 GC6830/20

POS DESCRIPTION 889682021160 889682230290 889682230300 889683020010
SWITZERLAND FRANCE RUSSIA WEU
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902278001 423902278011 423902278011 423902278001
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278061 423902278051 423902278051 423902278061
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278201 423902278211 423902278211 423902278201
19A TRAY ASSY 423902278301 423902278301 423902278301 423902278311
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
21 FRONT LOCK ASSY 423902278361 423902278371 423902278371 423902278361
22 FILLING DOOR MOLDED 423902278411 423902278421 423902278421 423902278411
23 WATER TANK ASSY 423902276671 423902276681 423902276681 423902276671
26 TUBE COVER MOLDED 423902278431 423902278431 423902278431 423902278451
27 STAND TOP MOLDED 423902278481 423902278481 423902278481 423902278461
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278541 423902278541 423902278551
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269622 423902269622 423902269602
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277831 423902277581 423902277581 423902277581
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 23 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6830/20 GC6830/20 GC6830/20 GC6830/20

POS DESCRIPTION 889683020180 889683020190 889683020290 889683020300
IBERIA NORDIC FRANCE RUSSIA
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902278001 423902278001 423902278001 423902278001
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278061 423902278061 423902278061 423902278051
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278201 423902278201 423902278201 423902278201
19A TRAY ASSY 423902278311 423902278311 423902278311 423902278311
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
21 FRONT LOCK ASSY 423902278361 423902278361 423902278361 423902278361
22 FILLING DOOR MOLDED 423902278411 423902278411 423902278411 423902278411
23 WATER TANK ASSY 423902276671 423902276671 423902276671 423902276671
26 TUBE COVER MOLDED 423902278451 423902278451 423902278451 423902278451
27 STAND TOP MOLDED 423902278461 423902278461 423902278461 423902278461
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278551 423902278551 423902278551 423902278551
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269602 423902269602 423902269602 423902269602
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277581 423902277581 423902277581
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 24 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6830/20 GC6830/26 GC6833/30 GC6833/30

POS DESCRIPTION 889683020380 889683026150 889683330010 889683330040
ITALY UK WEU TURKEY
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902278001 423902278001 423902278011 423902278011
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278061 423902278061 423902278051 423902278051
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278201 423902278201 423902278211 423902278211
19A TRAY ASSY 423902278311 423902278311 423902278321 423902278321
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
21 FRONT LOCK ASSY 423902278361 423902278361 423902278371 423902278371
22 FILLING DOOR MOLDED 423902278411 423902278411 423902278421 423902278421
23 WATER TANK ASSY 423902276671 423902276671 423902276681 423902276681
26 TUBE COVER MOLDED 423902278451 423902278451 423902278441 423902278441
27 STAND TOP MOLDED 423902278461 423902278461 423902278471 423902278471
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278551 423902278551 423902278561 423902278561
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269602 423902269602 423902269602 423902269602
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277591 423902277581 423902277581
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 25 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6833/30 GC6833/30 GC6833/30 GC6833/30

POS DESCRIPTION 889683330180 889683330230 889683330290 889683330300
IBERIA S. AFRICA FRANCE RUSSIA
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902278011 423902278011 423902278011 423902278011
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278051 423902278051 423902278051 423902278051
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278211 423902278211 423902278211 423902278211
19A TRAY ASSY 423902278321 423902278321 423902278321 423902278321
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
21 FRONT LOCK ASSY 423902278371 423902278371 423902278371 423902278371
22 FILLING DOOR MOLDED 423902278421 423902278421 423902278421 423902278421
23 WATER TANK ASSY 423902276681 423902276681 423902276681 423902276681
26 TUBE COVER MOLDED 423902278441 423902278441 423902278441 423902278441
27 STAND TOP MOLDED 423902278471 423902278471 423902278471 423902278471
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278561 423902278561 423902278561 423902278561
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269602 423902269602 423902269602 423902269602
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277901 423902277581 423902277581
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 26 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6833/30 GC6833/30 GC6833/36 GC6833/36

POS DESCRIPTION 889683330410 889683330510 889683336150 889683336450
ARGENTINA CHILE UK HONG Kong
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902278011 423902278011 423902278011 423902278011
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278051 423902278051 423902278051 423902278051
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278211 423902278211 423902278211 423902278211
19A TRAY ASSY 423902278321 423902278321 423902278321 423902278321
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
21 FRONT LOCK ASSY 423902278371 423902278371 423902278371 423902278371
22 FILLING DOOR MOLDED 423902278421 423902278421 423902278421 423902278421
23 WATER TANK ASSY 423902276681 423902276681 423902276681 423902276681
26 TUBE COVER MOLDED 423902278441 423902278441 423902278441 423902278441
27 STAND TOP MOLDED 423902278471 423902278471 423902278471 423902278471
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278561 423902278561 423902278561 423902278561
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269602 423902269602 423902269602 423902269602
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277891 423902277581 423902277591 423902277591
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 27 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6802/36 GC6804/20 GC6821/30 GC6821/36

POS DESCRIPTION 889680236150 889680420290 889682130170 889682136150
UK FRANCE INDONESIA UK
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902278641 423902277981 423902278011 423902278011
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278071 423902278081 423902278051 423902278051
8 HOUSING PRTED 423902278101 423902278101 423902278101 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278191 423902278221 423902278211 423902278211
19A TRAY ASSY 423902278251 423902278261 423902278301 423902278301
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
21 FRONT LOCK ASSY - - 423902278371 423902278371
22 FILLING DOOR MOLDED 423902278401 423902278391 423902278421 423902278421
23 WATER TANK ASSY 423902276621 423902276611 423902276681 423902276681
26 TUBE COVER MOLDED 423902278431 423902278431 423902278431 423902278431
27 STAND TOP MOLDED 423902278481 423902278481 423902278481 423902278481
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278541 423902278541 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269622 423902269622 423902269622
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277591 423902277581 423902277581 423902277591
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 28 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6819/20 RI6833/32 RI6833/34 GC6802/30

POS DESCRIPTION 889681920010 886683332240 886683334240 889680230400
WEU BRAZIL BRAZIL EEU
1 DECO PLATE PRTED 423902278631 423902278631 423902278631 423902278631
2 INLAY-LIGHT STRIP ASSY MOLDED 423902278001 423902278011 423902278011 423902278641
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902278061 423902278051 423902278051 423902278071
8 HOUSING PRTED 423902278101 423902278111 423902278111 423902278101
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP (THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902278201 423902278241 423902278211 423902278191
19A TRAY ASSY 423902278301 423902278331 423902278331 423902278251
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
21 FRONT LOCK ASSY 423902278361 423902278371 423902278371 -
22 FILLING DOOR MOLDED 423902278411 423902278421 423902278421 423902278401
23 WATER TANK ASSY 423902276671 423902276681 423902276681 423902276621
26 TUBE COVER MOLDED 423902278431 423902278441 423902278441 423902278431
27 STAND TOP MOLDED 423902278481 423902278491 423902278471 423902278481
28 PUMP ASSY 423902276261 423902278501 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278521 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278571 423902278561 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269702 423902269602 423902269622
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277871 423902277881 423902277581
39 CALC CLEAN CONTAINER ASSY 423902278611 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 29 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists
GC6815/20 GC6815/20 GC6815/20 GC6815/26
POS DESCRIPTION V13 889681520010 V13 889681520400 V13 889681520530 V13 889681526600
WEU EEU AUSTRALIA MEA
1 DECO PLATE PRTED 423902287511 423902287511 423902287511 423902287511
2 INLAY-LIGHT STRIP ASSY MOLDED 423902287531 423902287531 423902287531 423902287531
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902287551 423902287551 423902287551 423902287551
8 HOUSING PRTED 423902287571 423902287571 423902287571 423902287571
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902287951 423902287951 423902287951 423902287951
19A TRAY ASSY 423902287631 423902287631 423902287631 423902287631
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
22 FILLING DOOR MOLDED 423902287651 423902287651 423902287651 423902287651
23 WATER TANK ASSY 423902287671 423902287671 423902287671 423902287671
26 TUBE COVER MOLDED 423902278431 423902278431 423902278431 423902278431
27 STAND TOP MOLDED 423902288211 423902288211 423902288211 423902288211
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278541 423902278541 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269622 423902269622 423902269622
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277581 423902277861 423902277591
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 30 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists
GC6840/20 GC6840/20 GC6840/21 GC6842/30
POS DESCRIPTION V13 889684020010 V13 889684020300 V13 889684021160 V13 889684230010
WEU EEU SWITZERLAND WEU
1 DECO PLATE PRTED 423902287511 423902287511 423902287511 423902287511
2 INLAY-LIGHT STRIP ASSY MOLDED 423902287531 423902287531 423902287531 423902287521
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902287551 423902287551 423902287551 423902287541
8 HOUSING PRTED 423902287571 423902287571 423902287571 423902287561
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP (THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902287951 423902287951 423902287951 423902287961
19A TRAY ASSY 423902287621 423902287621 423902287621 423902287621
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
21 FRONT LOCK ASSY 423902287731 423902287731 423902287731 423902287721
22 FILLING DOOR MOLDED 423902287651 423902287651 423902287651 423902278421
23 WATER TANK ASSY 423902287671 423902287671 423902287671 423902287661
26 TUBE COVER MOLDED 423902278431 423902278431 423902278431 423902278431
27 STAND TOP MOLDED 423902288211 423902288211 423902288211 423902287681
28 PUMP ASSY 423902276261 423902276261 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278541 423902278541 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269622 423902269622 423902269622
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277581 423902277831 423902277581
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 31 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6842/30 GC6842/30 GC6842/30 GC6842/32

POS DESCRIPTION V13 889684230300 V13 889684230410 V13 889684230640 V13 889684232240
EEU ARGENTINA THAILAND BRAZIL
1 DECO PLATE PRTED 423902287511 423902287511 423902287511 423902287511
2 INLAY-LIGHT STRIP ASSY MOLDED 423902287521 423902287521 423902287521 423902287521
3 HANDLE PCBA 423902275791 423902275791 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041 423902278041 423902278041
7 TRIGGER MOLDED 423902287541 423902287541 423902287541 423902287541
8 HOUSING PRTED 423902287561 423902287561 423902287561 423902287981
9 RUBBER CAP 423902278121 423902278121 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131 423902278131 423902278131
11 RUBBER CAP (THERMISTOR OPENING) 423902278141 423902278141 423902278141 423902278141
12 HOSE CLIP DIA 423902278151 423902278151 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902287961 423902287961 423902287961 423902287991
19A TRAY ASSY 423902287621 423902287621 423902287621 423902288001
19B TRAY CAP MOLDED 423902278341 423902278341 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351 423902278351 423902278351
21 FRONT LOCK ASSY 423902287721 423902287721 423902287721 423902287721
22 FILLING DOOR MOLDED 423902278421 423902278421 423902278421 423902278421
23 WATER TANK ASSY 423902287661 423902287661 423902287661 423902287661
26 TUBE COVER MOLDED 423902278431 423902278431 423902278431 423902278431
27 STAND TOP MOLDED 423902287681 423902287681 423902287681 423902288251
28 PUMP ASSY 423902276261 423902276261 423902276261 423902288011
29 BUTTON FRAME ASSY 423902278511 423902278511 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531 423902278531 423902278521
31 STAND BOTTOM MOLDED 423902278541 423902278541 423902278541 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591 423902278591 423902278591
35 SOLEPLATE ASSY 423902269622 423902269622 423902269622 423902269702
36 DOSING SEAL 423902278601 423902278601 423902278601 423902278601
37 MAINSCORD 423902277581 423902277891 423902287971 423902277871
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 32 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists

GC6842/34 GC6842/36
V13 889684234240 V13 889684236450
POS DESCRIPTION
BRAZIL HONG KONG
MALAYSIA
1 DECO PLATE PRTED 423902287511 423902287511
2 INLAY-LIGHT STRIP ASSY MOLDED 423902287521 423902287521
3 HANDLE PCBA 423902275791 423902275791
4 TRIGGER SPRING CAP MOLDED 423902278021 423902278021
5 LED HOLDER MOLDED 423902278031 423902278031
6 DOSING HEAD MOLDED 423902278041 423902278041
7 TRIGGER MOLDED 423902287541 423902287541
8 HOUSING PRTED 423902287981 423902287561
9 RUBBER CAP 423902278121 423902278121
10 RUBBER CAP (FUSE OPENING) 423902278131 423902278131
11 RUBBER CAP(THERMISTOR OPENING) 423902278141 423902278141
12 HOSE CLIP DIA5 423902278151 423902278151
13 HOSE SLEEVE 423902278161 423902278161
15 CHASSIS MOLDED 423902278171 423902278171
16 IRON BOTTOM CAP MOLDED 423902278181 423902278181
18 TRIMMED HOSE CORD MTD ASSY 423902287961 423902287961
19A TRAY ASSY 423902288021 423902287621
19B TRAY CAP MOLDED 423902278341 423902278341
20 TANK TOP SEAL 423902278351 423902278351
21 FRONT LOCK ASSY 423902287721 423902287721
22 FILLING DOOR MOLDED 423902278421 423902278421
23 WATER TANK ASSY 423902287661 423902287661
26 TUBE COVER MOLDED 423902278431 423902278431
27 STAND TOP MOLDED 423902287681 423902287681
28 PUMP ASSY 423902276261 423902276261
29 BUTTON FRAME ASSY 423902278511 423902278511
30 STAND PCBA 423902278531 423902278531
31 STAND BOTTOM MOLDED 423902278541 423902278541
32 CORD CLAMP MOLDED 423902278581 423902278581
34 COVER MOLDED 423902278591 423902278591
35 SOLEPLATE ASSY 423902269602 423902269622
36 DOSING SEAL 423902278601 423902278601
37 MAINSCORD 423902277881 423902277591
39 CALC CLEAN CONTAINER ASSY 423902278621 423902278621

Published by Philips Consumer Lifestyle Page 33 of 38 For internal use only

Document No. : CSW-07-081-17169
Service Lists
- Iron exploded view

Notes - Scale: Not to scale

Published by Philips Consumer Lifestyle Page 34 of 38 For internal use only
Document No. : CSW-07-081-17169
Service Lists
- Stand exploded view

Notes - Scale: Not to scale

Published by Philips Consumer Lifestyle Page 35 of 38 For internal use only
Document No. : CSW-07-081-17169
Revision History
Version Records Author Date
1 New release Cathy May 2017
2 Added in model GC6804/20 (889680420530) Cathy Sep 2017
Added in model GC6830/20 (889683020190)
Updated Parts lists
3 Update Parts List Seet BK 15th Mar 2018
Remove 17, 24A, 24B, 25 & 33 from the Disassembly
Instruction and Exploded View of the Service Manual
Removed the Following BOM:
GC6802/30; 889680230290, GC6804/20; 889680420290,
GC6804/20; 889680420300, GC6804/20; 889680420530,
GC6820/20; 889682020300, GC6830/20; 889683020010,
GC6830/20; 889683020180, GC6830/20; 889683020190,
GC6830/20; 889683020380, GC6833/30; 889683330180,
GC6833/30; 889683330181, GC6833/30; 889683330300,
GC6833/30; 889683330301, GC6833/36; 889683336151,
Add the following BOM:
GC6800/20; 889680020380, GC6804/20; 889680420040,
GC6833/30; 889683330040
Add in Pump Assembly Functional Test and Pump-PCBA
Calibration at section 8.6.
4 Update Parts List by adding the following: Seet BK 20th Apr 2018
GC6804/26; 889680426150, GDC6820/20; 889682020290
5 Add POS 38 ZULU THERMISTOR ASSY into existing Parts List. Seet BK 2nd Aug 2018
Update Parts List by adding the following:
GC6822/30; 889682230300, GC6830/20; 889683020190,
GC6830/20; 889683020300, GC6833/30; 889683330230,
RI6833/32; 886683332240, RI6833/34; 886683334240
Update Product Matrix and Exploded Views
Added in 8.6 LED Blinking Error Signal Interpretation
6 Update Repair Instruction Soleplate temperature Chong Yoke Lan 29th Aug 2018
measurement
7 Add new versions Seet BK 1st Oct 2018
889684230300; 889684230010; 889684020300;
889684021160; 889684236450; 889681520010;
889684020010 & 889681520400

Published by Philips Consumer Lifestyle Page 36 of 38 For internal use only

Document No. : CSW-07-081-17169
Record History
Version Records Author Date
7 Update Parts List by adding the following: Seet BK 1st Oct 2018
GC6801/20; 889680120380, GC6802/30; 889680230290,
GC6804/20; 889680420300, GC6804/20; 889680420530,
GC6808/20; 889680820010, GC6820/20; 889682020300,
GC6830/20; 889683020010, GC6830/20; 889683020180,
GC6830/20; 889683020380, GC6833/30; 889683330180,
GC6833/30; 889683330300, GC6802/30; 889680230600,
GC6804/21; 889680421160, GC6804/26; 889680426600,
GC6819/20; 889681920220, GC6820/21; 889682021160,
GC6822/30; 889682230300, GC6830/20; 889683020290,
GC6830/26; 889683026150, GC6833/30; 889683330010,
GC6833/30; 889683330040, GC6833/30; 889683330290,
GC6833/30; 889683330410, GC6833/30; 889683330510,
GC6833/36; 889683336150
Update Product Matrix, Product Information
Remove Electrical Diagram
8 Position number 23 Water Tank Assy Philips 12NC Chong Yoke Lan 13th Nov 2018
correction per SBOM to resolve IPM-148819 for following:
GC6820/20; 889682030300, GC6830/20; 889683020010,
GC6833/30; 889683330300
9 Update part list by adding following: Chong Yoke Lan 4th Apr 2019
GC6819/20; 889681920010, GC6802/36; 889681920150
Add POS 39 Calc Clean Container Assy to part list to
resolve IPM-152104.
Removed Phantom parts:
POS 28A Corrugated Elbow Tube Inlet
POS 28B Corrugated Elbow Tube Outlet
POS 28C Pump Support
POS 28D Hose Connector Molded
POS 28E Pressure Relief Valve Assy
POS 28F Rubber Junction
Update part number of POS 28 Pump Assy & POS 35
Soleplate Assy in part list.
Update Exploded View.

Published by Philips Consumer Lifestyle Page 37 of 38 For internal use only

Document No. : CSW-07-081-17169
Record History
Version Records Author Date
10 Update Product Matrix Chong Yoke Lan 17th Dec 2019
Update Disassembly Instruction
Update Exploded view
Update Repair Instruction
Add Trouble Shooting
Update part list with new service 12NC
Remove Pos. 14 Clamping Plate & Pos. 38 Thermistor Assy
Add 889683336450; 889680420290; 889682130170 &
88968236150
11 Update Factory Mode Test flow Chong Yoke Lan 24th Jan 2020
12 Update part list, add new version 889680230400 Chong Yoke Lan 13th Mar 2020
13 Update Product Matrix Chong Yoke Lan 10th Nov 2020
Update Functions/ features information
Add new versions
889684230300; 889684230010; 889684020300;
889684021160; 889684236450; 889681520010;
889684020010; 889681520400; 889681526600;
889681520530; 889684230410; 889684230640;
889684232240 & 889684234240

Published by Philips Consumer Lifestyle Page 38 of 38 For internal use only

Document No. : CSW-07-081-17169