Icom IC-F4001 Service Manual

UHF TRANSCEIVERS
S-14617XZ-C1
Nov. 2009
Downloaded from www.dlmanuals.com

INTRODUCTION CAUTION
This service manual describes the latest technical NEVER connect the transceiver to an AC outlet or to a DC
information for the IC-F4001/IC-F4002/IC-F4003/IC-F4006/ power supply that uses more than the specified voltage.
IC-F4008 UHF TRANSCEIVERS at the time of publication. This will ruin the transceiver.
CHANNEL FREQUENCY
DO NOT expose the transceiver to rain, snow or any liquids.
MODEL VERSION SPACING RANGE
DO NOT reverse the polarities of the power supply when
(kHz) (MHz)
connecting the transceiver.
USA-11
IC-F4001 USA-12 12.5/25.0 DO NOT apply an RF signal of more than 20 dBm (100 mW) to
the antenna connector. This could damage the transceiver’s
USA-13 front-end.
EUR-21
EUR-22 12.5/20.0/25.0
EUR-23
IC-F4002
UK-01
UK-02
UK-03
EXP-11
EXP-12
EXP-13
EXP-21 400–470
EXP-22
EXP-23
IC-F4003
EXP-01 12.5/25.0
EXP-03
EXP-31
AUS-21
AUS-22
AUS-23
RUS-21
IC-F4006 RUS-22
RUS-23
IC-F4008 CHN-31
To upgrade quality, any electrical or mechanical parts

and internal circuits are subject to change without notice
or obligation. (IC-F4001)
ORDERING PARTS REPAIR NOTES
1. Make sure that the problem is internal before

Be sure to include the following four points when ordering
disassembling the transceiver.
replacement parts:
2. DO NOT open the transceiver until the transceiver is
disconnected from its power source.
1. 10-digit Icom part number
3. DO NOT force any of the variable components. Turn
2. Component name
them slowly and smoothly.
3. Equipment model name and unit name
4. DO NOT short any circuits or electronic parts. An
4. Quantity required
insulated tuning tool MUST be used for all adjustments.
5. DO NOT keep power ON for a long time when the
<ORDER EXAMPLE> transceiver is defective.
1110003491 S.IC TA31136FNG IC-F4001 MAIN UNIT 5 pieces 6. DO NOT transmit power into a Standard Signal
8820001210 Screw 2438 screw IC-F4003 Top cover 10 pieces Generator or a Sweep Generator.
7. ALWAYS connect a 50 dB to 60 dB attenuator between
Addresses are provided on the inside back cover for your the transceiver and a Deviation Meter or Spectrum
convenience. Analyzer when using such test equipment.
8. READ the instructions of the test equipment throughly
before connecting it to the transceiver.
Icom, Icom Inc. and the Icom logo are registered trademarks of Icom Incorporated (Japan) in Japan, the United States, the
United Kingdom, Germany, France, Spain, Russia and/or other countries.

TABLE OF CONTENTS
SECTION 1 SPECIFICATIONS
SECTION 2 INSIDE VIEWS
SECTION 3 DISASSEMBLY INSTRUCTION
SECTION 4 CIRCUIT DESCRIPITON

4-1 RECEIVER CIRCUITS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
4-2 TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
4-3 FREQUENCY SYNTHESIZER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
4-4 VOLTAGE BLOCK DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
4-5 PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
SECTION 5 ADJUSTMENT PROCEDURES

5-1 PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
5-2 FREQUENCY ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
5-3 TRANSMIT ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
5-4 RECEIVE ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
SECTION 6 PARTS LIST
SECTION 7 MECHANICAL PARTS
SECTION 8 BOARD LAYOUTS
SECTION 9 BLOCK DIAGRAM
SECTION 10 VOLTAGE DIAGRAM

SECTION 1. SPECIFICATIONS
M GENERAL
• Frequency range : 400–470 MHz
• Number of conventional channels : 16 channels
• Type of emission : [EUR] Wide: 16K0F3E (25.0 kHz)
Middle: 14K0F3E (20.0 kHz)
Narrow: 8K50F3E (12.5 kHz)
Except [EUR] Wide: 16K0F3E (25.0 kHz)
Narrow: 11K0F3E (12.5 kHz)
• Antenna impedance : 50 Ω (Nominal)
• Operating temperature range : –30˚C to +60˚C; –22˚F to +140˚F Except [EUR], [UK]
–25˚C to +55˚C [EUR], [UK]
• Power supply voltage : Specified Icom's battery packs only (7.2 V DC; negative ground)
• Current drain (Approx.) : Receiving 70 mA (stand-by)
330 mA (max. audio)
Transmitting 1.3 A (at 4.0 W)
• Dimensions : With BP-264 58.6 (W)×111.0 (H)×31.0 (D) mm; 2 5/16 (W)×4 3⁄8 (H)×1 7⁄32 (D) in.
(Projections not included) With BP-265 58.6 (W)×111.0 (H)×35.5 (D) mm; 2 5/16 (W)×4 3⁄8 (H)×1 13⁄32 (D) in.
• Weight : With BP-264 Approx. 330 g; 11 21/32 oz.
With BP-265 Approx. 270 g; 9 17/32 oz.
• Intermediate frequency : 1st 46.35 MHz
2nd 450 kHz
• Output impedance (Audio) :8Ω
• Input impedance (Audio) : 2.2 kΩ
M TRANSMITTER
• Output power : 4W
• Modulation : Variable reactance frequency modulation
• Maximum frequency deviation : Narrow ±2.5 kHz
Middle ±4.0 kHz
Wide ±5.0 kHz
• Frequency stability : ±2.5 ppm
• Spurious emissions : 70 dB min. Except [EUR], [UK]
0.25 µW (≤1 GHz), 1.0 µW (>1 GHz) [EUR], [UK]
• Adjacent channel power : Narrow 60 dB min., 66 dB typ.
Middle 70 dB min., 73 dB typ.
Wide 70 dB min., 73 dB typ.
• Audio harmonic distortion : Wide, Middle 1.0% typ. at AF 1 kHz 40 % deviation
Narrow 1.5% typ. at AF 1 kHz 40 % Deviation
• FM hum and Noise (Except [EUR], [UK]) : Narrow 34 dB min., 40 dB typ.
(Without CCITT FILTER) Wide 40 dB min., 46 dB typ.
• Residual modulation ([EUR], [UK]) : Narrow 40 dB min.
(With CCITT FILTER) Middle 43 dB min.
Wide 45 dB min.
• Limitting charact of modulator : 60–100% of max. deviation
1-1
M RECEIVER
• Sensitivity : 0.25 µV typ. at 12 dB SINAD Except [EUR], [UK]
–4 dBµV (EMF) typ. at 20 dB SINAD [EUR], [UK]
• Squelch sensitivity (at threshold) : 0.25 µV typ. Except [EUR], [UK]
–4 dBµV (EMF) typ. [EUR], [UK]
• Intermodulation : 70 dB min. 74 dB typ. Except [EUR], [UK]
65 dB min. [EUR], [UK]
• Spurious response : 70 dB min.
• Audio output power : 0.8 W typ. at 5% distortion with 12 Ω (Int. speaker)
0.4 W typ. at 5% distortion with 8 Ω (Ext. speaker)
• Hum and noise (Except [EUR], [UK]) : Narrow 34 dB min. 47 dB typ.
(Without CCITT Filter) Wide 40 dB min. 52 dB typ.
• Hum and noise ([EUR], [UK]) : Narrow 40 dB min.
(With CCITT Filter) Middle 43 dB min.
Wide 45 dB min.
• Adjacent channel selectivity : Narrow 60 dB min. 65 dB typ.
Middle 70 dB min. 73 dB typ.
Wide 70 dB min. 73 dB typ.
Specifications are measured in accordance with TIA/EIA-603B or EN 300 086

All stated specifications are subject to change without notice or obligation.
1-2
SECTION 2. INSIDE VIEWS
• MAIN-A UNIT
(TOP VIEW)
+5V LINE REGULATOR

(Q75)
+5V LINE REGULATOR

(Q76)
CPU5 LINE REGULATOR

(IC54)
APC AMP
(IC1)
TCXO
(X2) PLL IC
(IC2)
2ND IF BPF
(FI2)
2ND IF BPF (For narrow mode only)

VCO (FI3)
LPF
MIC GAIN CONTROLLER (Q51)
(IC62)
LED CTRL
(Q82,Q83)
HPF BEEP SW
(IC58) (IC61)
TONE FILTER SW
(Q52)
TONE LPF
(IC59)
MIC/AF LINE SW
(IC56)
2-1
• MAIN-A UNIT
(BOTTOM VIEW)
+5V LINE REGULATOR

(Q74)
AF AMP
(IC55)
TUNED BPF
(D24, D26)
POWER CTRL
(Q63) RF AMP
(Q22)
AGC CTRL
(Q21)
POWER AMP
(Q1)
XTAL BPF
(FI1)
DRIVE AMP
(Q2)
1ST IF MIXER
(Q23) PRE-DRIVE AMP
(Q3)
IF DEMODULATOR IC PRE-AMP
(IC3) (Q4)
BUFFER
(Q9)
R5 LINE REGULATOR
(Q72) RIPPLE FILTER
(Q15)
S5 LINE REGULATOR
(Q71) BUFFER
(IC60)
CLONE BUFFER
(Q81, D51)
D/A CONVERTER
(IC57)
CPU
(IC51)
RESET IC EEPROM
(IC53) (IC52)
2-2
SECTION 3. DISASSEMBLY INSTRUCTION
1. REMOVING THE CHASSIS

1) Remove the ANT connector nut and 2 knobs. 4) CAREFULLY lift the chassis out of the FRONT PANEL
and turn it over in order to unplug the speaker wire.
KNOBS
CHASSIS
ANT CONNECTOR NUT
SPEAKER
WIRE
FRONT PANEL
5) Remove the seals and nuts from the CHASSIS.

FRONT PANEL
2) Remove 2 screws from the bottom of the CHASSIS.

3) Lift the bottom of the CHASSIS up in the direction TOP SEAL
CHASSIS
of the arrow.
BE CAREFUL to not pull out the speaker wire when

separating the CHASSIS and the FRONT PANEL. NUTS×2 SIDE SEAL
SCREWS×2
CHASSIS
2. REMOVING THE MAIN UNIT

1) Remove the 9 screws and the side plate from the
MAIN UNIT.
2) Unsolder the 2 points shown, and then remove the
FRONT PANEL
MAIN UNIT.
For easy separation of the CHASSIS

Use a suction lifter to lift the bottom of the CHASSIS up.
UNSOLDER
Solder
remover
MAIN UNIT
Suction lifter
• Part name : EA950R-2 SIDE PLATE
• Manufacture : ESCO CO.LTD
Suction lifter SCREWS×9

CHASSIS
MAIN UNIT
(Continued to the right above)

3-1
SECTION 4. CIRCUIT DESCRIPTION
4-1 RECEIVER CIRCUITS

RF CIRCUITS 2ND IF CIRCUITS AND DEMODULATOR
The RX signal from the antenna is passed through the LPF The signal from the 1st IF circuits is applied to the IF
and antenna SW, then filtered by the 2-staged tuned BPF demodulator IC which contains the 2nd IF mixer, 2nd IF
to eliminate unwanted out-of-band signal. The filtered RX AMP, FM detector, etc. in its package.
signal is amplified by the RF AMP, and filtered by another
2-staged tuned BPF to obtain a good image response, then The 1st IF signal is applied to the 2nd IF mixer and mixed
applied to the 1st IF circuits. with the 2nd LO signal resulting in the 450 kHz 2nd IF
signal.
The tuned BPFs are tuned to the RX frequency by applying
adequate tuning voltages; “T1” and “T2” to the variable The 2nd LO signal is generated by tripling the 15.3 MHz
capacitors. reference frequency signal oscillated by the reference
frequency oscillator (TCXO).
• RF CIRCUITS The converted 2nd IF signal is filtered by the crystal filter/
ANT
filters to eliminate unwanted signal, and amplified by the
D3,D22
2nd IF AMP, then demodulated by the detector circuit which
From the TX circuits ANT
SW
LPF employs a discriminator as the phase shifter.
D28 Q22 D24,D26
To the 1st IF circuits RF

The demodulated AF signal is applied to the RX AF circuits.
BPF AMP BPF
T2 T1
• 2ND IF CIRCUITS
X2
15.3MHz
TCXO
1ST IF CIRCUITS Q26
The RX signal from the RF circuits is applied to the 1st IF X3

PLL
IC
IC2
MB15A02
mixer and mixed with the 1st LO signal from the RX VCO,
resulting in the 46.35 MHz 1st IF signal. The 1st IF signal is
filtered by the crystal filter, amplified by the 1st IF AMP, then 45.9MHz
BPF IF IC
From the 1st IF
applied to the 2nd IF circuits. IC3:NJM2591
circuits
D/A
• 1ST IF CIRCUITS converter
D31,D32 FI2
450kHz
W/N CERAMIC
SW BPF X1
D5,D6 SQIN
RX VCO Q10 Q8
LO To the TX circuits FI3 Discriminator
BUFF BUFF
SW 450kHz
DISC CERAMIC W/N
Q27,
BPF SW
IC57 D33,D34
R2A20178 NOIS
NWC
LPF
FI1 To the RX AF circuits

Q24 Q23
46.35MHz
To the 2nd IF&demodulator circuits IF XTAL From the RF circuits
AMP BPF
1st IF mixer
4-1
RX AF CIRCUITS 4-2 TRANSMITTER CIRCUITS
The demodulated AF signal from the IF demodulator TX AF CIRCUITS
IC is passed through the LPF, HPF which attenuates The audio signal from the internal or external microphone
frequencies 300 Hz and below. The filtered AF signal is (MIC signal) is passed through the MIC gain SW and applied
passed through the AF line SW, HPF which additionally to the MIC AMP. The amplified MIC signal is passed through
attenuates frequencies 300 Hz and below, de-emphasis the MIC mute SW, HPF which attenuates frequencies
circuit which provides –6 dB/oct of frequency response. 300 Hz and below. The filtered MIC signal is passed through
The de-emphasized AF signal is passed through the AF the pre-emphasis circuit which provides +6 dB/oct of
SW, LPF which attenuates frequencies 3 kHz and above, is frequency response, then they applied to the limiter AMP.
adjusted in level by the D/A converter. The level-adjusted AF
signal is then applied to the AF power AMP via the AF line The amplitude-limited MIC signal is passed through the
SW. MIC line SW, and applied to the splatter filter, which
attenuate harmonics in the MIC signal to prevent exceeding
The amplified AF signal is applied to the internal or external permissible deviation.
speaker.
• RX AF CIRCUITS The filtered MIC signal is applied to the D/A converter which
RMUT 1 adjusts its level (=deviation). The level-adjusted MIC signal
IC59 IC58 IC62 is applied to the TX VCO as the modulation signal.
LPF HPF RX
the demodulator MUTE
circuits
IC58
LPF
HPF
• TX AF CIRCUITS
IC58 J51
AF line SW
IC55 TPA0211DGN Ext.MIC
J52 IC58
Ext.speaker
D/A
AFO AF IC57
LPF
AM P IC58 IC62 IC62
IC57 IC58 IC60
R2A20178 IC56 Splatter MIC
MIC limit MIC MIC
CD4066 HPF AMP GAIN
line AMP MUTE SW
D/A SW MC51
IC12 Int.MIC
converter TA7368F J53
MOD
1 To the modulation circuits
AF IC56
2
AM P CD4066
AFON SP1
Int.speaker
MODULATION CIRCUIT
The modulation signal from the TX AF circuits is applied to
D15 of the TX VCO to frequency-modulate it. The frequency-
modulated signal from the TX VCO is buffer-amplified by
two buffers, and applied to the TX AMP circuits via the TX/
RX SW (D5).
• MODULATION CIRCUITS
D5,D6
TX VCO Q10 Q8
LO To the TX AMP circuits
Q14,D16 BUFF BUFF SW
D15
FREQUENCY
MODULATION
From the TX AF circuits
4-2
TX AMPLIFIERS 4-3 FREQUENCY SYNTHESIZER CIRCUITS
The buffer amplified signal from the LO SW (D5) is amplified The RX VCO is composed of Q13, D11 and D12. The VCO
by; the pre-AMP, pre-drive AMP, drive AMP, and power AMP output signal is buffer-amplified by two buffers and applied
in sequence, to obtain TX power. The amplified TX signal to the 1st IF mixer, via the LO SW (D6) and the LPF.
is passed through the antenna SW and the LPF, which
eliminates harmonics, and then fed to the antenna. The TX VCO is composed of Q14 and D14–D16. The VCO
output signal is buffer-amplified by two buffers and applied
to the 1st IF mixer, via the LO SW (D6) and the LPF.
APC CIRCUITS
D1 and D2 rectify a portion of the TX signal to direct current, A portion of oscillated signal from each VCO is fed back to
and the APC AMP compares the voltage and the TX power the PLL IC via the buffer and the LPF.
control reference voltage, “T1.” The resulting voltage controls
the gain of the power and drive AMPs to keep the TX power The applied VCO output signal is divided and phase-
constant. compared with a 15.3 MHz reference frequency signal from
the TCXO, which is also divided. The resulting signal is
• TX AMPLIFIERS AND APC CIRCUIT output from the PLL IC, and DC-converted by the loop filter,
ANT
and then applied to the VCO as the lock voltage.
Q4 Q3 Q2 Q1 D3,D22
From the
TX VCO PRE
AM P
PRE
DRIVE DRIVE PWR LPF
ANT
LPF
When the oscillation frequency drifts, its phase changes
AM P AM P SW
from that of the reference frequency, causing a lock voltage
IC1
change to compensate for the drift in the VCO oscillating
APC PWR D1,D2 frequency.
AMP T1 DET
Q6
To the RX circuits MUTE

SW
TMUT
• FREQUENCY SYNTHESIZER CIRCUITS
D11
RX VCO
LV Q13,D12
ADJ
X2 LOOP
LV D5,D6
IC60 FILTER
BAL Q10 Q8
15.3MHz LO
BUFF TCXO BUFF BUFF To the TX AMPs
REF D14 SW
TX VCO
LVA LV
ADJ
Q26 IC2 Q14,D16
PLL Q9 LPF
X3
IC
LPF BUFF
SO,SCL,PLST Q23
45.9MHz IF IC 1st IF mixer
BPF IC3
4-4 VOLTAGE BLOCK DIAGRAM

Q73
T5C
T5 T5V
REG To the TX circuits
Q72
Q74-76 R5C
PWON R5 R5V
+5V REG
To the RX circuits
VCC REG
Q71
S5 S5V
S5 S5C REG
To both RX and TX circuits
+5V
To both RX and TX circuits
IC54
CPU5 CPU5
REG
To the logical circuits
4-3
4-5 PORT ALLOCATIONS
• CPU (IC51)
PIN LINE PIN LINE
NO. NAME
DESCRIPTION I/O
NO. NAME
DESCRIPTION I/O
Tone signal (CTCSS/DTCS) A/D conversion select.

1 CDEC I 51 ADSW O
decoding input. H=RSSI input, L=BATV input
Tone signal (5/2 TONE, DTMF, Noise level detect.
2 STONE I/O 53 NOIS I
BIIS) decoding/encoding . H=Squelch close
Clock frequency shift. 54 UNLK PLL unlock detect. I
13 CSFT O
H=Clock frequency is shifted. RX AF mute switch control.
RX mode (narrow/wide) 55 RMUT2 O
L=AF mute.
switching. RX AF mute switch control.
14 NWC O 56 RMUT1 O
L=While receiving in the narrow L=AF mute.
mode MIC mute switch control.
External PTT input. 57 MMUT O
15 EPTT I L=MIC mute.
H=An external PTT is pushed. Transmission mute.
Automatic TX control for VOX 58 TMUT O
L=TX inhibit.
16 ATX mode. O External microphone connection
H=Microphone input is detected. 59 MDET I
detect.
17 BEEP Beep sounds. (Square waves) O 60 LVIN Lock voltage input. I
AF power AMP control.
61 TEMP Temperature sensing voltage. I
18 AFON H=A F p owe r A M P ( I C 5 5 ) i s O
activated. 62 AFVI [VOLUME CONTROL] input. I
19 SCK Common clock. O 63 VOXV Microphone input sensing voltage. I
20 SO Common serial data. O Remaining battery voltage.
[UPPER] key input. (or)
22 KEY2 I 64 AD5 RSSI voltage. I
L=Pushed
(The input signal depends on the
[LOWER] key input.
23 KEY1 I status of pin 51.)
L=Pushed
PLL strobe.
24 PLST I/O
H=Load enable.
D/A converter strobe. • D/A CONVERTER (IC57)
25 DAST I/O
H=Load enable. PIN LINE
DESCRIPTION
26 ESDA EEPROM data. I/O No. NAME
27 ESCL EEPROM clock. I/O 23 T1 BPF tuning voltage
Power supply switching control. (TXPO) TX power control
28 R5C H=S u p p l y i n g c u r r e n t t o t h e O 24 T2 BPF tuning voltage
receiver circuits ("R5"line).
7 REF Reference frequency adjust voltage.
Power supply switching control.
29 T5C H=S u p p l y i n g c u r r e n t t o t h e O 8 LVA Additional lock voltage adjustment.
transmitter circuits ("T5"line). 11 SQLC Squelch threshold setting.
Power supply switching control. 12 TENC CTCSS deviation adjustment.
30 S5C H=Supplying current to the RX/ O
TX common circuits ("S5"line). 19 BAL DTCS balance.
Power supply switching control. 20 VRAF Max. deviation/AF volume adjustment.
31 PWON H=The transceiver's power is O
ON.
Internal PTT input.
32 IPTT I
L=PTT pushed.
33, CENC2,
34, CENC1, CTCSS/DTCS signal. O
36 CENC0
37– CBI0–
[ROTARY SELECTOR] input. I
40 CBI3
Frequency response switching.
41 DUSE O
H=DTCS encoding
Busy LED (Green) control.
42 RLED O
L=LED lights. (Squelch open)
Busy LED (Red) control.
43 TLED O
L=LED lights. (Transmit)
47 MGC0 MIC gain control. O
48 MGC1 MIC gain control. O
49 CLI I
Cloning data.
50 CLO O
4-4
SECTION 5. ADJUSTMENT PROCEDURE
5-1 PREPARATION
¤ REQUIRED EQUIPMENTS
EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE
CS-F3000 CLONING SOFTWARE Modified OPC-478/U/UC
Cloning software JIG cable
(Revision 1.0 or later) (See the illusted below)
Measuring range : 0.1–6 W Frequency range : 0.1–600 MHz
RF power meter
Frequency range : 100–600 MHz Frequency counter Frequency accuracy : ±1 ppm or better
(50 Ω terminated)
SWR : Less than 1.2 : 1 Input level : Less than 1 mW
Modulation Frequency range : 30–600 MHz Frequency range : 0.1–600 MHz
Analyzer Measuring range : 0 to ±10 kHz Standard signal
Output level : –20 to 90 dBµ
generator (SSG)
AC millivoltmeter Measuring range : 10 mV to 10 V (–127 to –17 dBm)
Frequency range : DC–20 MHz Power attenuation : 30 dB
Oscilloscope Attenuator
Measuring range : 0.01–20 V Capacity : More than 6 W
Audio generator Frequency range : 300–3000 Hz Input impedance :8Ω
External speaker
(AG) Output level : 1–500 mV Capacity : More than 1 W
¤ JIG CABLE
AC
AUDIO GENERATOR MILLIVOLTMETER
[JIG cable1] (300–3000 Hz/1–500 mV) (10 mV to 10 V)
(GND) SETTING;
Frequency : 1 kHz
PTT + − Level : 1−500mV + −
Waveform : Sine wave
3-conductor 2.5 (d) mm plug 33 k
+
(MIC)
4.7 µF
[JIG cable2]
(SP) + EXT. SPEAKER
− (1 W/8 Ω)
(GND)
3-conductor 3.5(d) mm plug OPC-478/U/UC
(CLONE)
5-1
¤ CONNECTION
OPC-478
(RS-232C type) to RS-232C port
Standard signal generator PC
to the antenna connector
–20 to 90 dBµ
(–127 to –17 dBm) to USB port
OPC-478U
NEVER transmit while (USB type)
an SSG is connected to to USB port
the antenna connector.
FM Attenuator
deviation meter 30 dB OPC-478UC
(USB type)
RF power meter
0.1– 6 W/50 Ω
Frequency To [SP] connector

counter
To [MIC]
Speaker (8 Ω)
To [SP]
JIG cables
5-2
¤ ADJUSTMENT CHANNELS
Before starting the adjustments, use the cloning software to create the same cloning file as shown below, then upload it
into the transceiver.
CONVENIENT: The same cloning file is available.

Right-click below, and select "Save Embeded File to
Disk."
For [EUR] versions:

When adjusting “Deviation” in the middle band, change the
bandwidth to “Middle” as shown below.
Select “Middle”
5-3
¤ ADJUSTMENT UTILITY
Click or [Read <– TR] in the [Adjust] menu to open the "Adjust Utility" window as shown below.
Click to open the
“I/O Check window”
ADJ. CHANNEL
TX OUTPUT POWER
MOD. BALANCE
DEVIATION
CTCSS\DTCS
SQUELCH
REF. FREQUENCY
RX SENSITIVITY
LOCK VOLTAGE
(Adjustment)
If the below window appears, the utility is password-protected.

Enter the password to open the "Adjust Utility" window.
5-4
5-2 FREQUENCY ADJUSTMENTS
1) Select an adjustment item using [↑]/[↓] on the PC's keyboard.
2) Set or modify the adjustment value as specified using [←]/[→] on the PC's keyboard, then push [ENTER].
TRANSCEIVER’S ADJUSTMENT
ADJUSTMENT OPERATION VALUE
CONDITION ITEM
PLL LOCK 1 • Connect an RF power meter to the
VOLTAGE – antenna connector. – –
-Adjustment-
(RX) 2 • CH. :1 • Select the item [RX LVA], then push 1.0 V
[RX LVA]
• Receiving [ENTER].
(TX) 3 • CH. :1 • Select the item [TX LVA], then push 1.0 V
[TX LVA]
• Transmitting [ENTER].
PLL LOCK 1 • CH. :2 • Click the [Reload (F5)] button to check 3.0–4.0 V
VOLTAGE • Receiving on the "I/O Check window" as illustrated (Verify)
-Verify- below. [LVIN]
(RX) (On the "I/O
Check window")
(TX) 2 • CH. :2 2.7–3.9 V
• Transmitting (Verify)
REFERENCE 1 • CH. :3 • Loosely couple a frequency counter to the 470.0000 MHz
FREQUENCY • Transmitting antenna connector. [REF] (±300 Hz)
• I/O Check window
*** Lock voltage
(The values shown above are example only.

Each transceiver has own values.)
5-5
5-3 TRANSMIT ADJUSTMENTS
CONDITION ITEM
TX OUTPUT 1 • CH. :4 • Connect an RF power meter to the
POWER • Transmitting antenna connector. [Power (Hi)] 4.0 W
(Hi power)
(L2 power) 2 • CH. :5
[Power (L2)] 2.0 W
• Transmitting
(L1 power) 3 • CH. :6
[Power (L1)] 1.0 W
• Transmitting
MODULATION 1 • CH. :7 • Connect a modulation analyzer with an Square
BALANCE • Transmitting oscilloscope to the antenna connector waveform
through an attenuator.
[BAL]
FM DEVIATION 1 • CH. :8 • Connect a modulation analyzer to the ±2.05 to ±2.15

[MOD N C]
(Narrow mode) • Transmitting antenna connector through an attenuator. kHz
(Middle mode)* 2 • CH. :9 ±3.25 to ±3.35
[MOD M C]
• Transmitting kHz
(Wide mode) 3 • CH. :9 ±4.05 to ±4.15
[MOD W C]
• Transmitting kHz
CTCSS/DTCS 1 • CH. : 10 • Connect a modulation analyzer to the ±0.65 to ±0.75
DEVIATION • Transmitting antenna connector through an attenuator. [CTCSS/DTCS] kHz
*; [EUR] versions only
5-6
5-4 RECEIVE ADJUSTMENTS
CONDITION ITEM
RX SENSITIVITY 1 • CH. : 11 1) C o n n e c t a n S S G t o t h e a n t e n n a (Automatic
• Receiving connector and set it as; adjustment)
Frequency : 435 MHz
Level* : 20 dBµ (–87 dBm)
[BPF ALL]
Modulation : 1 kHz
Deviation : ±3 kHz
2) Put the cursor on the adjustment item,
then push [ENTER].
SQUELCH 1 • CH. : 12 1) C o n n e c t a n S S G t o t h e a n t e n n a (Automatic
• Receiving connector and set it as; adjustment)
Frequency : 400 MHz
Level* : –13 dBµ (–120 dBm)
Modulation : 1 kHz [SQL]
Deviation : ±1.5 kHz
2) Once close the squelch by increasing
[SQL] value, then decrease the value to
open the squelch.
3) Push [ENTER] key to store the value.
*; The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.
5-7
SECTION 6. PARTS LIST
[MAIN-A UNIT] [MAIN-A UNIT]

REF PARTS H/V REF PARTS H/V
DESCRIPTION M. LOCATION DESCRIPTION M.
NO. NO. NO. NO. LOCATION
IC1 1110002751 S.IC TA75S01F(TE85R,F) T 32.5/8.8 L3 6200013010 S.COI 0.30-0.9-5TL 10.3N <COMO> B 12.7/13.4
IC2 1140005991 S.IC MB15A02PFV1-G-BND-ERE1 T 42.9/24.7 L4 6200002851 S.COI NLV25T-R82J B 18.2/16.6
IC3 1110007320 S.IC NJM2591V-TE1-#ZZZB B 45.8/38.9 L5 6200012610 S.COI 0.40-0.9-2TL 2.8N <COMO> B 18.2/13.4
IC51 1140015230 S.IC R4F20102NFA (EMPTY) B 77.7/38 L6 6200012610 S.COI 0.40-0.9-2TL 2.8N <COMO> B 20.7/13.4
IC52 1130015240 S.IC R1EX24016ATA00A B 85/25.2 L7 6200012980 S.COI 0.40-1.4-5TR 18.3N <COMO> B 23.6/13.4
IC53 1110007620 S.IC NJU7704F3-42A-TE1-#ZZZB B 87.6/44.6 L8 6200013860 S.COI MLK1005S12NJT B 41/10.7
IC54 1180003600 S.REG NJM2871BF05-TE1-#ZZZB T 15.6/34.8 L9 6200013840 S.COI MLK1005S18NJT B 45.5/10.7
IC55 1110007610 S.IC TPA0211DGNR B 13.8/42.1 L11 6200010850 S.COI LQW18AN22NG00D
IC56 1130011770 S.IC CD4066BPWR T 80.1/18.8 (LQW1608A22NG00) B 13.9/16.6
IC57 1110007550 S.IC R2A20178NP B 72.5/24.5 L13 6200007700 S.COI LQW2BHN22NJ03L B 15.1/22.4
IC58 1110005340 S.IC NJM12902V-TE1-#ZZZB T 80.1/12 L14 6200007700 S.COI LQW2BHN22NJ03L B 15.2/28.1
IC59 1110006350 S.IC LM2902PWR T 80.1/25.9 L15 6200007680 S.COI LQW2BHN12NJ03L B 25.8/27.6
IC60 1110005340 S.IC NJM12902V-TE1-#ZZZB B 65.1/7.5 L16 6200007680 S.COI LQW2BHN12NJ03L B 32.7/27.6
IC61 1140013200 S.IC CD4053BPWR T 80.1/38.3 L18 6200013800 S.COI MLK1005S39NJT B 36.4/23.5
IC62 1130011770 S.IC CD4066BPWR T 66.7/8.1 L19 6200013780 S.COI MLK1005S56NJT B 34.4/25.1
L20 6200004770 S.COI ELJNC R56J-F B 39.4/27.7
L23 6200012170 S.COI MLG1608SR18J-T T 39.4/34.6
Q1 1560001700 S.FET RD07MUS2B-T112 B 28.6/13.5 L24 6200012170 S.COI MLG1608SR18J-T T 41.5/31.8
Q2 1560001241 S.FET RD01MUS1-T113 B 36.1/14.4 L31 6200013810 S.COI MLK1005S33NJT T 53.8/17.7
Q3 1530000371 S.TRA 2SC3356-T1B S (R25) B 41.3/12.9 L32 6200013810 S.COI MLK1005S33NJT B 56.3/20.4
Q4 1530003311 S.TRA 2SC5107-O(TE85R,F) B 46.2/13.4 L33 6200013830 S.COI MLK1005S22NJT T 59.2/18.3
Q6 1590004050 S.TRA LDTA144EET1G <SLVJ> T 33.3/5.9 L35 6190002030 S.COI MLG1608S 1R0J-T B 59.1/26.6
Q8 1530003311 S.TRA 2SC5107-O(TE85R,F) T 55.6/18.6 L36 6200013580 S.COI 0.30-0.9-4TR 5PER <COMO> T 54.3/26.1
Q9 1530003311 S.TRA 2SC5107-O(TE85R,F) B 58.1/19.4 L37 6190002030 S.COI MLG1608S 1R0J-T T 56.5/28.7
Q10 1530003311 S.TRA 2SC5107-O(TE85R,F) T 61/19.1 L40 6200013630 S.COI 0.30-0.9-3TR 5.8N 5PER
Q11 1590004070 S.TRA LDTC144EET1G <SLVJ> B 50.8/25.2 <COMO> T 63.8/24.9
Q12 1590004070 S.TRA LDTC144EET1G <SLVJ> B 63/23.6 L41 6200011860 S.COI LQW18ANR47G00D T 58.9/27.4
Q13 1530002920 S.TRA 2SC4226-T1 R25 T 56.5/22.6 L42 6190002030 S.COI MLG1608S 1R0J-T T 60.5/28.8
Q14 1530002920 S.TRA 2SC4226-T1 R25 T 62.2/22.3 L47 6200013840 S.COI MLK1005S18NJT B 51.3/20.4
Q15 1530002851 S.TRA 2SC4116-BL(TE85R,F) B 62.7/16.2 L48 6200013990 S.COI MLK1005S1N0ST B 32.7/13.1
Q17 1560000541 S.FET 2SK880-Y(T5RICOM,F) B 52.6/29.5
Q19 1590004070 S.TRA LDTC144EET1G <SLVJ> B 63.5/33.6
Q21 1560000841 S.FET 2SK1829(TE85R,F) B 25.7/31.5 R1 7030005070 S.RES ERJ2GEJ 683 X (68K) B 7.2/5.5
Q22 1580000731 S.FET 3SK293(TE85L,F) B 21.2/29 R2 7030009140 S.RES ERJ2GEJ 272 X (2.7K) B 12.5/8.9
Q23 1580000731 S.FET 3SK293(TE85L,F) B 36.4/27.3 R3 7030005120 S.RES ERJ2GEJ 102 X (1K) B 14.1/8
Q24 1530002601 S.TRA 2SC4215-O(TE85R,F) B 38.3/42.6 R4 7030005120 S.RES ERJ2GEJ 102 X (1K) B 14.1/8.9
Q25 1590004070 S.TRA LDTC144EET1G <SLVJ> T 49.3/35.1 R5 7030009140 S.RES ERJ2GEJ 272 X (2.7K) B 12.5/10.9
Q26 1530002851 S.TRA 2SC4116-BL(TE85R,F) T 39.6/30.1 R6 7030004990 S.RES ERJ2GEJ 221 X (220) B 20.3/17.9
Q27 1590004050 S.TRA LDTA144EET1G <SLVJ> B 56/36.4 R11 7030009140 S.RES ERJ2GEJ 272 X (2.7K) T 29.9/5.9
Q51 1590001650 S.TRA XP4601(TX) T 65.5/42 R12 7030005050 S.RES ERJ2GEJ 103 X (10K) T 31.7/5.9
Q52 1590004070 S.TRA LDTC144EET1G <SLVJ> T 75.4/31.4 R13 7030005090 S.RES ERJ2GEJ 104 X (100K) T 32.6/11.3
Q58 1590003431 S.TRA UNR911HG0L B 54.9/7.1 R14 7030005310 S.RES ERJ2GEJ 124 X (120K) T 30.8/11.3
Q59 1590004070 S.TRA LDTC144EET1G <SLVJ> B 49.1/7.3 R15 7030005170 S.RES ERJ2GEJ 474 X (470K) T 34.8/5.9
Q63 1520000460 S.TRA 2SB1132 T100 R B 15.1/35.5 R16 7030005530 S.RES ERJ2GEJ 100 X (10) T 35.7/9.6
Q64 1590001190 S.TRA XP6501-(TX).AB B 19.3/36 R17 7030008280 S.RES ERJ2GEJ 271 X (270) T 34.8/7.6
Q71 1510001090 S.TRA KTA2015Y-RTK/P B 65.1/36.6 R18 7030005120 S.RES ERJ2GEJ 102 X (1K) T 35.7/7.6
Q72 1510000771 S.TRA 2SA1586-GR(TE85L,F) B 65.7/30.3 R21 7030005530 S.RES ERJ2GEJ 100 X (10) B 33.2/10.8
Q73 1510001090 S.TRA KTA2015Y-RTK/P B 78.6/23.8 R22 7030005040 S.RES ERJ2GEJ 472 X (4.7K) B 34.1/9.1
Q74 1520000460 S.TRA 2SB1132 T100 R B 5.3/34.4 R23 7030005060 S.RES ERJ2GEJ 333 X (33K) B 32.3/9.1
Q75 1590001190 S.TRA XP6501-(TX).AB T 4.5/35.2 R26 7030004970 S.RES ERJ2GEJ 470 X (47) B 38.2/10.8
Q76 1590004070 S.TRA LDTC144EET1G <SLVJ> T 6.8/35.2 R27 7030005040 S.RES ERJ2GEJ 472 X (4.7K) B 38.2/9.1
Q81 1590003271 S.TRA UNR9210G0L B 70.5/45.8 R29 7030004970 S.RES ERJ2GEJ 470 X (47) B 41/9.8
Q82 1590004050 S.TRA LDTA144EET1G <SLVJ> T 71.6/39.5 R30 7030005220 S.RES ERJ2GEJ 223 X (22K) B 41.8/15.1
Q83 1590004050 S.TRA LDTA144EET1G <SLVJ> T 71.6/41.6 R31 7030004980 S.RES ERJ2GEJ 101 X (100) B 45.5/9.8
Q84 1590004070 S.TRA LDTC144EET1G <SLVJ> B 19.2/44.1 R32 7030005220 S.RES ERJ2GEJ 223 X (22K) B 45.7/15.2
Q85 1590004070 S.TRA LDTC144EET1G <SLVJ> B 22.4/44.1 R33 7030005050 S.RES ERJ2GEJ 103 X (10K) B 49.6/13.1
R34 7030004980 S.RES ERJ2GEJ 101 X (100) B 49.6/14
R35 7030005040 S.RES ERJ2GEJ 472 X (4.7K) B 51.8/16.6
D1 1750001800 S.DIO RB886CS T2RA B 13.8/6.6 R41 7030005530 S.RES ERJ2GEJ 100 X (10) T 57.4/17.7
D2 1750001800 S.DIO RB886CS T2RA B 13.8/10.5 R42 7030005070 S.RES ERJ2GEJ 683 X (68K) T 57.4/19.3
D3 1750001890 S.DIO HVD142AKRF-E B 15.7/14.8 R43 7030004980 S.RES ERJ2GEJ 101 X (100) B 54.5/18.8
D5 1750001890 S.DIO HVD142AKRF-E B 49.6/15.2 R44 7030005090 S.RES ERJ2GEJ 104 X (100K) B 59.9/18.9
D6 1750001890 S.DIO HVD142AKRF-E B 49.6/16.6 R45 7030004980 S.RES ERJ2GEJ 101 X (100) T 63.2/17.9
D11 1750001550 S.VAR HVD376BKRF-E T 56.8/26.4 R46 7030005090 S.RES ERJ2GEJ 104 X (100K) T 62.8/19.3
D12 1750001840 S.VAR HVD350BKRF-E T 54/28.7 R51 7030005010 S.RES ERJ2GEJ 681 X (680) B 52.8/25.2
D14 1750001550 S.VAR HVD376BKRF-E T 60.4/26.1 R52 7030008370 S.RES ERJ2GEJ 561 X (560) B 61.5/22.3
D15 1750001650 S.VAR 1SV309(TPH3,F) T 64.6/28.2 R53 7030006020 S.RES RR0510P-682-D (6.8K) T 58.3/23.8
D16 1750001840 S.VAR HVD350BKRF-E T 62.5/28.2 R54 7030006020 S.RES RR0510P-682-D (6.8K) T 58.1/25.4
D18 1750001810 S.DIO L1SS400T1G <SLVJ> T 46.3/32.6 R55 7030006020 S.RES RR0510P-682-D (6.8K) T 59.5/23.8
D21 1750001810 S.DIO L1SS400T1G <SLVJ> B 28.1/33.3 R56 7030006020 S.RES RR0510P-682-D (6.8K) T 60.3/25.1
D22 1750001890 S.DIO HVD142AKRF-E B 15.7/18.3 R57 7030009320 S.RES ERJ2GEJ 4R7 X (4.7) T 61.9/24.2
D24 1750001780 S.VAR HVB350BYPTL-E B 18.1/23.8 R63 7030005220 S.RES ERJ2GEJ 223 X (22K) B 62.6/27.7
D26 1750001780 S.VAR HVB350BYPTL-E B 18.1/26.7 R64 7030005530 S.RES ERJ2GEJ 100 X (10) T 64.2/26.4
D28 1750001780 S.VAR HVB350BYPTL-E B 29.2/26.7 R65 7030005600 S.RES ERJ2GEJ 273 X (27K) B 64.4/26.1
D31 1750001790 S.DIO 1SS390 TE61 B 54.1/39.8 R66 7030005100 S.RES ERJ2GEJ 154 X (150K) B 65.4/26.1
D32 1750001790 S.DIO 1SS390 TE61 B 51.7/36.8 R67 7030007290 S.RES ERJ2GEJ 222 X (2.2K) B 60.9/16.4
D35 1750001810 S.DIO L1SS400T1G <SLVJ> T 37.5/6.3 R71 7030005050 S.RES ERJ2GEJ 103 X (10K) B 50.3/29.5
D51 1750001820 S.DIO LRB706F-40T1G <SLVJ> B 67.9/45.8 R72 7030004980 S.RES ERJ2GEJ 101 X (100) B 49.9/27.9
D52 1750001790 S.DIO 1SS390 TE61 B 87/33.7 R73 7030005040 S.RES ERJ2GEJ 472 X (4.7K) B 55.6/30.5
D53 1750001810 S.DIO L1SS400T1G <SLVJ> B 69.1/3.1 R76 7030005120 S.RES ERJ2GEJ 102 X (1K) T 49.1/25.5
D55 1750001810 S.DIO L1SS400T1G <SLVJ> B 21.9/33.8 R77 7030008410 S.RES ERJ2GEJ 392 X (3.9K) T 46.7/25.5
R78 7030005120 S.RES ERJ2GEJ 102 X (1K) T 46.7/24.3
R80 7410001130 S.ARR EXB28V102JX T 44.4/29.9
FI1 2030000870 S.MON MFT46.3P3 46.350 MHz (FL-442) B 36.2/34.6 R81 7030005100 S.RES ERJ2GEJ 154 X (150K) B 62/35.3
FI2 2020002460 CER LTM450GW <JJE> R82 7030005050 S.RES ERJ2GEJ 103 X (10K) T 40.1/19.4
FI3 2020002570 CER LTM450HW <JJE> R83 7030005580 S.RES ERJ2GEJ 560 X (56) T 46.7/20.9
R87 7030005090 S.RES ERJ2GEJ 104 X (100K) T 63.5/27.7
R88 7510001730 S.THE ERTJOEP 473J T 56.6/13.3
X1 6070000310 S.DIS JTBM450CX70 <JJE> T 47.6/40.9 R89 7030010080 S.RES ERJ2RHD 104 X (100K) T 58.3/13.3
X2 6050012050 S.XTA CR-794 TTS14VSB-A6 15.3 MHz T 41.9/15 R101 7030005110 S.RES ERJ2GEJ 224 X (220K) B 28.1/32.1
X51 6050012730 S.XTA CR-864 (SMD-49/12.288 MHz) R102 7030005170 S.RES ERJ2GEJ 474 X (470K) B 25.8/33.3
<JJE> T 86.9/38.5 R103 7030008400 S.RES ERJ2GEJ 182 X (1.8K) B 28.1/30.9
R104 7030005050 S.RES ERJ2GEJ 103 X (10K) B 18.1/21.8
R105 7030005050 S.RES ERJ2GEJ 103 X (10K) B 20.3/27.2
L1 6200012490 S.COI 0.30-0.9-6TR 13.6N <COMO> B 9.5/7.5 R106 7030005240 S.RES ERJ2GEJ 473 X (47K) B 18.3/29
L2 6200012490 S.COI 0.30-0.9-6TR 13.6N <COMO> B 10.6/10.5 R107 7030005050 S.RES ERJ2GEJ 103 X (10K) B 20.2/31
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
S.=Surface mount
6-1
NO. NO. DESCRIPTION M. LOCATION DESCRIPTION M. LOCATION
NO. NO.
R108 7030005080 S.RES ERJ2GEJ 823 X (82K) B 19.2/29 R386 7030005060 S.RES ERJ2GEJ 333 X (33K) T 73.6/13.8
R109 7030005530 S.RES ERJ2GEJ 100 X (10) B 21.2/31 R387 7030005030 S.RES ERJ2GEJ 152 X (1.5K) T 73.6/15.6
R110 7030004980 S.RES ERJ2GEJ 101 X (100) B 22.1/25.4 R388 7030008010 S.RES ERJ2GEJ 123 X (12K) B 78.8/13.7
R112 7030004970 S.RES ERJ2GEJ 470 X (47) B 25.8/25.4 R389 7030005800 S.RES RR0510P-102-D (1K) B 77.9/13.7
R113 7030007300 S.RES ERJ2GEJ 332 X (3.3K) B 24.2/28.5 R390 7030005810 S.RES RR0510P-152-D (1.5K) B 77.2/15.5
R114 7030005090 S.RES ERJ2GEJ 104 X (100K) B 27.4/26.8 R391 7030007290 S.RES ERJ2GEJ 222 X (2.2K) T 74.5/15.6
R115 7030005090 S.RES ERJ2GEJ 104 X (100K) B 31/26.8 R393 7030005700 S.RES ERJ2GEJ 274 X (270K) B 61.7/7.8
R116 7030005310 S.RES ERJ2GEJ 124 X (120K) B 35.4/29.3 R394 7030005090 S.RES ERJ2GEJ 104 X (100K) B 60.8/6.2
R121 7030007300 S.RES ERJ2GEJ 332 X (3.3K) B 41.2/27.7 R401 7030005120 S.RES ERJ2GEJ 102 X (1K) T 66.2/35.8
R122 7030004970 S.RES ERJ2GEJ 470 X (47) B 43.3/25.1 R402 7030005000 S.RES ERJ2GEJ 471 X (470) B 68.5/22.5
R123 7030005530 S.RES ERJ2GEJ 100 X (10) B 39.2/29.8 R403 7030010040 S.RES ERJ2GEJ-JPW B 67.5/28.7
R126 7030007290 S.RES ERJ2GEJ 222 X (2.2K) B 39/40.8 R408 7030004980 S.RES ERJ2GEJ 101 X (100) B 35.6/46.3
R127 7030005090 S.RES ERJ2GEJ 104 X (100K) B 37.3/40.8 R412 7030005040 S.RES ERJ2GEJ 472 X (4.7K) B 16.8/38.3
R128 7030005010 S.RES ERJ2GEJ 681 X (680) B 39.1/44.4 R413 7030005090 S.RES ERJ2GEJ 104 X (100K) T 19.8/32.2
R135 7030007290 S.RES ERJ2GEJ 222 X (2.2K) T 43/36.7 R417 7030007340 S.RES ERJ2GEJ 153 X (15K) B 21.3/37.1
R136 7030007290 S.RES ERJ2GEJ 222 X (2.2K) T 43/37.6 R418 7030005120 S.RES ERJ2GEJ 102 X (1K) B 19.8/37.9
R137 7030008410 S.RES ERJ2GEJ 392 X (3.9K) T 45.7/35.1 R420 7030005090 S.RES ERJ2GEJ 104 X (100K) T 79.6/32.3
R138 7030005000 S.RES ERJ2GEJ 471 X (470) B 43/35.5 R421 7210003061 VAR TP76N00N-15F-A103-2251A
R139 7030005090 S.RES ERJ2GEJ 104 X (100K) B 48.3/35.5 R423 7030005090 S.RES ERJ2GEJ 104 X (100K) T 6.9/37.8
R140 7030008410 S.RES ERJ2GEJ 392 X (3.9K) B 46.5/34.6 R424 7030005090 S.RES ERJ2GEJ 104 X (100K) T 5.2/38.7
R143 7030005040 S.RES ERJ2GEJ 472 X (4.7K) B 48.3/32.8 R428 7030005030 S.RES ERJ2GEJ 152 X (1.5K) B 65.1/3.1
R146 7030004970 S.RES ERJ2GEJ 470 X (47) B 45.6/44 R429 7030006610 S.RES ERJ2GEJ 394 X (390K) B 66.8/3.1
R147 7030005030 S.RES ERJ2GEJ 152 X (1.5K) B 47.1/42.2 R430 7030005160 S.RES ERJ2GEJ 105 X (1M) B 71.7/3.1
R148 7030005120 S.RES ERJ2GEJ 102 X (1K) T 37.8/31.4 R431 7030005050 S.RES ERJ2GEJ 103 X (10K) B 66.6/34.8
R149 7030007060 S.RES ERJ2GEJ 684X (680K) T 37.8/29.6 R432 7030005040 S.RES ERJ2GEJ 472 X (4.7K) B 70.5/30.9
R151 7030005600 S.RES ERJ2GEJ 273 X (27K) B 51.7/39 R433 7030005050 S.RES ERJ2GEJ 103 X (10K) B 67.5/30.3
R152 7030005210 S.RES ERJ2GEJ 822 X (8.2K) B 53.9/35.1 R434 7030005050 S.RES ERJ2GEJ 103 X (10K) B 70.5/30
R153 7030007300 S.RES ERJ2GEJ 332 X (3.3K) B 55.5/38.5 R435 7030005050 S.RES ERJ2GEJ 103 X (10K) B 76.8/24.5
R154 7030005210 S.RES ERJ2GEJ 822 X (8.2K) B 57.5/36.9 R436 7030005040 S.RES ERJ2GEJ 472 X (4.7K) B 75.4/30
R156 7030005120 S.RES ERJ2GEJ 102 X (1K) B 20.3/21.8 R438 7030007290 S.RES ERJ2GEJ 222 X (2.2K) T 4.8/33.3
R157 7030005120 S.RES ERJ2GEJ 102 X (1K) B 31/25.1 R439 7030007290 S.RES ERJ2GEJ 222 X (2.2K) T 83.2/8.4
R158 7030005120 S.RES ERJ2GEJ 102 X (1K) B 59.4/35.7 R440 7030009280 S.RES ERJ2GEJ 391 X B 17.5/43.6
R159 7030005290 S.RES ERJ2GEJ 682 X (6.8K) B 29.7/23.8 R441 7030005050 S.RES ERJ2GEJ 103 X (10K) B 20.8/43.6
R301 7030007340 S.RES ERJ2GEJ 153 X (15K) B 68.4/12.4 R442 7030007280 S.RES ERJ2GEJ 331 X (330) B 20.2/33.7
R302 7030008010 S.RES ERJ2GEJ 123 X (12K) B 66.6/12.4 R451 7030005530 S.RES ERJ2GEJ 100 X (10) B 85.2/37.3
R304 7030005030 S.RES ERJ2GEJ 152 X (1.5K) B 69.3/10.7 R454 7030005220 S.RES ERJ2GEJ 223 X (22K) B 87/32.2
R312 7030005220 S.RES ERJ2GEJ 223 X (22K) T 64.6/39.6 R457 7030005040 S.RES ERJ2GEJ 472 X (4.7K) T 80.7/35
R313 7030007300 S.RES ERJ2GEJ 332 X (3.3K) T 62.6/39.6 R458 7030005120 S.RES ERJ2GEJ 102 X (1K) B 81.3/30
R314 7030006610 S.RES ERJ2GEJ 394 X (390K) T 63.7/41.2 R459 7030005120 S.RES ERJ2GEJ 102 X (1K) B 80.4/30
R315 7030005080 S.RES ERJ2GEJ 823 X (82K) T 63.7/42.8 R460 7410001140 S.ARR EXB28V104JX B 77.7/30
R316 7030005000 S.RES ERJ2GEJ 471 X (470) T 67.3/42.8 R461 7030005040 S.RES ERJ2GEJ 472 X (4.7K) B 84/30.8
R317 7030005290 S.RES ERJ2GEJ 682 X (6.8K) T 66.4/39.6 R462 7030005040 S.RES ERJ2GEJ 472 X (4.7K) B 84/29.9
R318 7030005050 S.RES ERJ2GEJ 103 X (10K) T 67.3/39.6 R463 7030005050 S.RES ERJ2GEJ 103 X (10K) T 71.8/37.7
R321 7030007340 S.RES ERJ2GEJ 153 X (15K) T 73.7/27.7 R464 7030005090 S.RES ERJ2GEJ 104 X (100K) T 73.4/34.8
R322 7030008300 S.RES ERJ2GEJ 184 X (180K) B 69.1/33 R466 7410001140 S.ARR EXB28V104JX B 69.5/40
R323 7030005720 S.RES ERJ2GEJ 563 X (56K) B 70/33 R467 7410001140 S.ARR EXB28V104JX B 69.5/37
R324 7030005220 S.RES ERJ2GEJ 223 X (22K) B 70.9/33 R468 7030008400 S.RES ERJ2GEJ 182 X (1.8K) T 70/41.6
R325 7030005290 S.RES ERJ2GEJ 682 X (6.8K) T 72.8/29.5 R469 7030009280 S.RES ERJ2GEJ 391 X T 70/39.5
R329 7030005040 S.RES ERJ2GEJ 472 X (4.7K) T 77.9/29.5 R473 7410001140 S.ARR EXB28V104JX B 77.7/46.1
R331 7030005240 S.RES ERJ2GEJ 473 X (47K) T 77.4/31.6 R475 7030005090 S.RES ERJ2GEJ 104 X (100K) B 79.5/30
R343 7030005070 S.RES ERJ2GEJ 683 X (68K) T 84.8/27.7
R344 7030005070 S.RES ERJ2GEJ 683 X (68K) T 86.6/27.7
R345 7030005070 S.RES ERJ2GEJ 683 X (68K) T 85.7/26 C1 4030011650 S.CER C1005 CH 1H 1R5B-T B 8.5/5.7
R346 7030005240 S.RES ERJ2GEJ 473 X (47K) T 85.7/24.3 C2 4030009720 S.CER C1005 CH 1H 080C-T B 10.6/5.7
R347 7030005050 S.RES ERJ2GEJ 103 X (10K) B 81.3/15.4 C3 4030011630 S.CER C1005 CH 1H 0R5B-T B 12.5/8
R348 7030005090 S.RES ERJ2GEJ 104 X (100K) T 82.3/34.6 C4 4030011650 S.CER C1005 CH 1H 1R5B-T B 9.1/10.5
R349 7030005160 S.RES ERJ2GEJ 105 X (1M) T 83.2/34.6 C5 4030009720 S.CER C1005 CH 1H 080C-T B 10.7/14.9
R350 7030005050 S.RES ERJ2GEJ 103 X (10K) T 86.6/24.3 C6 4030011630 S.CER C1005 CH 1H 0R5B-T B 12.5/10
R351 7030008290 S.RES ERJ2GEJ 183 X (18K) T 75.5/24.3 C7 4030019740 S.CER C1005 JB 1H 102K-T B 14.9/6.6
R352 7030005050 S.RES ERJ2GEJ 103 X (10K) T 71.8/12 C8 4030011670 S.CER C1005 CH 1H 2R5B-T B 12.4/14.9
R353 7030005210 S.RES ERJ2GEJ 822 X (8.2K) T 72.7/10.2 C9 4030011700 S.CER C1005 CH 1H 040B-T B 12.4/15.8
R354 7030005160 S.RES ERJ2GEJ 105 X (1M) T 75.4/10.2 C10 4030019740 S.CER C1005 JB 1H 102K-T B 14.8/13.4
R359 7030005210 S.RES ERJ2GEJ 822 X (8.2K) B 56.1/10.5 C12 4030009720 S.CER C1005 CH 1H 080C-T B 17.7/11.8
R360 7030007290 S.RES ERJ2GEJ 222 X (2.2K) B 56.1/9.6 C13 4030009760 S.CER C1005 CH 1H 150J-T B 19.7/11.8
R361 7030005000 S.RES ERJ2GEJ 471 X (470) B 25.1/43.9 C14 4030007050 S.CER C1608 CH 1H 220J-T B 21.4/10.3
R362 7030005060 S.RES ERJ2GEJ 333 X (33K) B 51.6/7.5 C18 4030019740 S.CER C1005 JB 1H 102K-T B 19.8/19.1
R363 7030005000 S.RES ERJ2GEJ 471 X (470) B 57.8/8.7 C19 4030019740 S.CER C1005 JB 1H 102K-T B 18.2/19.2
R364 7030005090 S.RES ERJ2GEJ 104 X (100K) T 59.5/5.5 C20 4030019740 S.CER C1005 JB 1H 102K-T T 33.5/11.3
R366 7030005100 S.RES ERJ2GEJ 154 X (150K) B 57.8/9.6 C21 4030019740 S.CER C1005 JB 1H 102K-T T 30.8/5.9
R369 7030005100 S.RES ERJ2GEJ 154 X (150K) T 61.7/10.4 C23 4030019930 S.CER C1005 JB 1A 104K-T T 31.7/11.3
R370 7030005170 S.RES ERJ2GEJ 474 X (470K) B 61.7/11 C24 4030019950 S.CER C1005 JB 0J 224K-T T 35.7/5.9
R371 7030005290 S.RES ERJ2GEJ 682 X (6.8K) T 74.5/8.4 C25 4030019810 S.CER C1005 JB 1E 103K-T T 35.7/11.3
R372 7030009290 S.RES ERJ2GEJ 562 X (5.6K) T 80.2/8.4 C26 4030019740 S.CER C1005 JB 1H 102K-T T 36.6/9.6
R374 7030008410 S.RES ERJ2GEJ 392 X (3.9K) T 86.5/10.2 C28 4030019970 S.CER C1005 JB 0J 105K-T T 37.5/7.6
R375 7030005000 S.RES ERJ2GEJ 471 X (470) T 85.6/12 C29 4030019740 S.CER C1005 JB 1H 102K-T B 37.3/9.1
R377 7030005060 S.RES ERJ2GEJ 333 X (33K) T 84.7/13.8 C36 4030011320 S.CER C1005 CH 1H 470J-T B 23.8/16.1
R384 7030005090 S.RES ERJ2GEJ 104 X (100K) T 80.9/15.4 C51 4030011700 S.CER C1005 CH 1H 040B-T B 39.1/14.2
R385 7030005310 S.RES ERJ2GEJ 124 X (120K) T 74.5/13.8 C52 4030019740 S.CER C1005 JB 1H 102K-T B 41/8.9
S.=Surface mount
6-2
NO. NO. DESCRIPTION M. DESCRIPTION M.
LOCATION NO. NO. LOCATION
C53 4030014260 S.CER C1005 JB 1H 331K-T B 42.7/10.7 C216 4030019740 S.CER C1005 JB 1H 102K-T B 41.4/25.1
C54 4030019740 S.CER C1005 JB 1H 102K-T B 42.7/9.8 C217 4030019810 S.CER C1005 JB 1E 103K-T B 40.4/25.1
C55 4030009740 S.CER C1005 CH 1H 100C-T B 39.1/12.5 C218 4030019810 S.CER C1005 JB 1E 103K-T B 37.6/29.8
C57 4030014260 S.CER C1005 JB 1H 331K-T B 37.3/10.8 C220 4030009710 S.CER C1005 CH 1H 070C-T B 40.4/34.6
C59 4030019650 S.CER C1005 CH 1H 050B-T B 43.7/14 C221 4030011320 S.CER C1005 CH 1H 470J-T B 42.4/25.1
C60 4030011320 S.CER C1005 CH 1H 470J-T B 45.5/8.9 C223 4030019740 S.CER C1005 JB 1H 102K-T B 43.3/23.5
C62 4030009720 S.CER C1005 CH 1H 080C-T B 45.5/11.6 C225 4030019810 S.CER C1005 JB 1E 103K-T B 39/39.8
C63 4030019650 S.CER C1005 CH 1H 050B-T B 47.4/15.2 C226 4030019810 S.CER C1005 JB 1E 103K-T B 37.3/44.4
C65 4030019740 S.CER C1005 JB 1H 102K-T B 51.2/14 C228 4030011630 S.CER C1005 CH 1H 0R5B-T B 35.6/39.8
C71 4030009740 S.CER C1005 CH 1H 100C-T T 52.9/17.7 C231 4030010250 S.CER C1005 CH 1H 101J-T B 40.9/41.8
C72 4030019740 S.CER C1005 JB 1H 102K-T B 55.4/17.1 C232 4030009770 S.CER C1005 CH 1H 220J-T T 43/38.6
C73 4030019740 S.CER C1005 JB 1H 102K-T T 53.8/19.3 C233 4030019740 S.CER C1005 JB 1H 102K-T B 40.9/39
C74 4030019650 S.CER C1005 CH 1H 050B-T T 58.3/19.3 C234 4030019810 S.CER C1005 JB 1E 103K-T T 47.3/35.1
C76 4030019740 S.CER C1005 JB 1H 102K-T B 56.3/18.8 C235 4030019490 S.CER C2012 JB 1A 106K-T B 44.5/42.6
C77 4030019740 S.CER C1005 JB 1H 102K-T T 64.6/19.3 C236 4030019740 S.CER C1005 JB 1H 102K-T B 47.1/43.1
C79 4030019930 S.CER C1005 JB 1A 104K-T B 64.5/16.4 C239 4030014260 S.CER C1005 JB 1H 331K-T T 43/39.6
C81 4030011680 S.CER C1005 CH 1H 030B-T T 58.3/17.7 C241 4030011320 S.CER C1005 CH 1H 470J-T B 46.5/32.8
C82 4030011320 S.CER C1005 CH 1H 470J-T B 55.4/18.8 C242 4030019680 S.CER C1005 CH 1H 181J-T B 48.3/34.6
C83 4030011720 S.CER C1005 CH 1H R75B-T T 58.3/22.2 C243 4030019680 S.CER C1005 CH 1H 181J-T B 46.5/35.5
C84 4030014260 S.CER C1005 JB 1H 331K-T T 54.4/22.7 C244 4030019930 S.CER C1005 JB 1A 104K-T B 50.2/37
C85 4030019740 S.CER C1005 JB 1H 102K-T T 54.4/21.8 C251 4030011680 S.CER C1005 CH 1H 030B-T T 41.5/34.6
C86 4030009710 S.CER C1005 CH 1H 070C-T T 56.5/24.5 C252 4030010090 S.CER C1005 CH 1H 560J-T T 39.4/33.4
C87 4030009830 S.CER C1005 CH 1H 180J-T T 54.4/23.6 C253 4030009840 S.CER C1005 CH 1H 060C-T T 41.5/33.6
C88 4030009830 S.CER C1005 CH 1H 180J-T T 56.5/25.4 C254 4030010090 S.CER C1005 CH 1H 560J-T T 39.4/32.5
C89 4030009790 S.CER C1005 CH 1H 330J-T T 56.8/27.6 C255 4030019810 S.CER C1005 JB 1E 103K-T T 41.5/29.6
C90 4030011650 S.CER C1005 CH 1H 1R5B-T T 53.6/27.6 C256 4030009740 S.CER C1005 CH 1H 100C-T T 39.2/24.6
C91 4030019970 S.CER C1005 JB 0J 105K-T B 59.6/28.9 C257 4030019810 S.CER C1005 JB 1E 103K-T T 36.9/31.4
C92 4030010080 S.CER C1005 CH 1H 240J-T T 55.2/27.6 C261 4030019930 S.CER C1005 JB 1A 104K-T B 50.5/38.6
C94 4030011320 S.CER C1005 CH 1H 470J-T T 49.1/26.4 C263 4030019810 S.CER C1005 JB 1E 103K-T B 57.1/41.5
C101 4030011630 S.CER C1005 CH 1H 0R5B-T T 59.5/22.2 C264 4030019810 S.CER C1005 JB 1E 103K-T B 53.9/36
C102 4030019930 S.CER C1005 JB 1A 104K-T T 64.2/20.6 C265 4030019810 S.CER C1005 JB 1E 103K-T B 58.7/36.9
C103 4030019740 S.CER C1005 JB 1H 102K-T T 64.2/21.5 C266 4030019810 S.CER C1005 JB 1E 103K-T B 57.4/35.1
C104 4030011700 S.CER C1005 CH 1H 040B-T T 60.4/23.8 C267 4030019930 S.CER C1005 JB 1A 104K-T T 50.9/34.6
C105 4030009730 S.CER C1005 CH 1H 090C-T T 64.2/22.4 C301 4030019930 S.CER C1005 JB 1A 104K-T B 69.3/12.4
C106 4030009760 S.CER C1005 CH 1H 150J-T T 61.9/25.1 C302 4030019850 S.CER C1005 JB 1E 183K-T B 66.6/14.1
C107 4030009790 S.CER C1005 CH 1H 330J-T T 60.6/27.4 C303 4030019690 S.CER C1005 CH 1H 221J-T B 68.4/10.7
C108 4030019650 S.CER C1005 CH 1H 050B-T T 64.2/23.3 C304 4030019460 S.CER C1608 JB 0J 106M-T T 62.6/42
C109 4030019740 S.CER C1005 JB 1H 102K-T B 61.7/29.9 C305 4030019900 S.CER C1005 JB 1A 473K-T T 76.4/32.9
C110 4030011630 S.CER C1005 CH 1H 0R5B-T T 62.6/26.4 C306 4030019890 S.CER C1005 JB 1A 393K-T T 65.5/37.9
C111 4030020040 S.CER C1005 CH 1H 200J-T T 61.5/27.4 C307 4030019930 S.CER C1005 JB 1A 104K-T T 63.5/39.6
C116 4030019970 S.CER C1005 JB 0J 105K-T B 64.4/27.7 C308 4030019800 S.CER C1005 JB 1H 682K-T T 65.5/39.6
C117 4030013880 S.CER C1005 JB 1H 222K-T B 63.5/27.7 C309 4030019860 S.CER C1005 JB 1E 223K-T T 67.3/41.2
C118 4030011320 S.CER C1005 CH 1H 470J-T B 65.9/24.9 C310 4030019930 S.CER C1005 JB 1A 104K-T T 62.6/37.9
C120 4030019740 S.CER C1005 JB 1H 102K-T B 61.7/31.8 C312 4030019850 S.CER C1005 JB 1E 183K-T T 74.6/29.5
C121 4030019490 S.CER C2012 JB 1A 106K-T B 61.9/19.3 C313 4030019930 S.CER C1005 JB 1A 104K-T T 77/29.5
C122 4030019810 S.CER C1005 JB 1E 103K-T B 60.9/14.8 C314 4030019750 S.CER C1005 JB 1H 122K-T T 74.6/26
C127 4030013890 S.CER C1005 JB 1H 152K-T B 63.5/29.9 C321 4030019740 S.CER C1005 JB 1H 102K-T T 85.7/29.4
C132 4550000270 S.TAN TEESVA 1E 474M8R T 48.9/29.5 C322 4030019740 S.CER C1005 JB 1H 102K-T T 85.7/27.7
C133 4030019900 S.CER C1005 JB 1A 473K-T T 46.7/26.4 C323 4030019710 S.CER C1005 JB 1H 391K-T T 84.8/26
C134 4550000460 S.TAN TEESVA 1C 105M8R T 46.7/29.5 C324 4030019810 S.CER C1005 JB 1E 103K-T T 86.6/26
C141 4030009840 S.CER C1005 CH 1H 060C-T B 55.4/20.4 C325 4030011320 S.CER C1005 CH 1H 470J-T T 87.5/26
C142 4030009710 S.CER C1005 CH 1H 070C-T B 53.5/18.8 C326 4030019810 S.CER C1005 JB 1E 103K-T T 71.8/15.6
C147 4030009710 S.CER C1005 CH 1H 070C-T B 51.3/19.5 C328 4030019970 S.CER C1005 JB 0J 105K-T T 72.8/24.3
C149 4030019740 S.CER C1005 JB 1H 102K-T T 46.7/21.8 C329 4030013910 S.CER C1005 JB 1H 472K-T T 74.6/24.3
C150 4030019740 S.CER C1005 JB 1H 102K-T T 43.1/20.3 C330 4030019810 S.CER C1005 JB 1E 103K-T T 72.7/13.8
C152 4030019740 S.CER C1005 JB 1H 102K-T T 43.1/18.5 C331 4030019810 S.CER C1005 JB 1E 103K-T T 72.7/12
C153 4030011320 S.CER C1005 CH 1H 470J-T T 44.5/32.6 C332 4030013910 S.CER C1005 JB 1H 472K-T T 73.6/10.2
C154 4030011320 S.CER C1005 CH 1H 470J-T T 43.6/32.6 C333 4030013910 S.CER C1005 JB 1H 472K-T T 74.5/10.2
C155 4030011320 S.CER C1005 CH 1H 470J-T T 42.7/32.6 C334 4030019740 S.CER C1005 JB 1H 102K-T B 15/46.6
C156 4030019930 S.CER C1005 JB 1A 104K-T T 48.6/32.6 C335 4030019740 S.CER C1005 JB 1H 102K-T B 26/43.9
C157 4030019810 S.CER C1005 JB 1E 103K-T T 41/19.4 C336 4030019970 S.CER C1005 JB 0J 105K-T B 56.1/8.7
C158 4030009740 S.CER C1005 CH 1H 100C-T T 39.2/19.4 C337 4030019740 S.CER C1005 JB 1H 102K-T B 52.5/7.5
C159 4030019930 S.CER C1005 JB 1A 104K-T T 40.1/10.9 C338 4030019740 S.CER C1005 JB 1H 102K-T B 50.7/7.5
C171 4030011700 S.CER C1005 CH 1H 040B-T B 15.3/16 C340 4030019930 S.CER C1005 JB 1A 104K-T B 57.8/10.5
C172 4030011660 S.CER C1005 CH 1H 020B-T B 15.3/17.2 C342 4030019740 S.CER C1005 JB 1H 102K-T B 47.1/6.4
C177 4030009840 S.CER C1005 CH 1H 060C-T B 15.8/24.8 C347 4030019810 S.CER C1005 JB 1E 103K-T T 82.2/8.4
C178 4030011660 S.CER C1005 CH 1H 020B-T B 14.5/25.2 C348 4030019890 S.CER C1005 JB 1A 393K-T T 81.2/8.4
C179 4030009840 S.CER C1005 CH 1H 060C-T B 15.8/25.7 C349 4030019930 S.CER C1005 JB 1A 104K-T T 85.6/10.2
C180 4030009780 S.CER C1005 CH 1H 270J-T B 15.8/26.6 C350 4030019750 S.CER C1005 JB 1H 122K-T T 86.5/13.8
C181 4030009710 S.CER C1005 CH 1H 070C-T B 17.4/29 C351 4030019690 S.CER C1005 CH 1H 221J-T T 85.6/15.6
C182 4030019740 S.CER C1005 JB 1H 102K-T B 20.3/22.7 C352 4030019930 S.CER C1005 JB 1A 104K-T T 86.5/12
C184 4030019930 S.CER C1005 JB 1A 104K-T B 20.3/26.3 C356 4030019490 S.CER C2012 JB 1A 106K-T B 76.9/28
C186 4030019930 S.CER C1005 JB 1A 104K-T B 19.2/31 C357 4030019810 S.CER C1005 JB 1E 103K-T T 83.2/33
C188 4030019740 S.CER C1005 JB 1H 102K-T B 23.2/31 C358 4030019930 S.CER C1005 JB 1A 104K-T T 82.3/33
C194 4030019740 S.CER C1005 JB 1H 102K-T B 22.1/27.2 C363 4030019930 S.CER C1005 JB 1A 104K-T B 69/28.7
C195 4030011670 S.CER C1005 CH 1H 2R5B-T B 23.2/28.5 C364 4030013910 S.CER C1005 JB 1H 472K-T B 60.8/9.4
C196 4030009750 S.CER C1005 CH 1H 120J-T B 27.4/28.5 C365 4030011320 S.CER C1005 CH 1H 470J-T B 61.7/4.6
C197 4030011630 S.CER C1005 CH 1H 0R5B-T B 29.2/28.9 C371 4030013910 S.CER C1005 JB 1H 472K-T T 73.6/12
C198 4030009750 S.CER C1005 CH 1H 120J-T B 31/28.5 C372 4030019680 S.CER C1005 CH 1H 181J-T T 75.4/13.8
C199 4030011670 S.CER C1005 CH 1H 2R5B-T B 34.4/26.8 C373 4030019900 S.CER C1005 JB 1A 473K-T T 74.5/17.4
C200 4030009760 S.CER C1005 CH 1H 150J-T B 34.4/28.5 C376 4030019740 S.CER C1005 JB 1H 102K-T B 77/13.7
C201 4030019740 S.CER C1005 JB 1H 102K-T B 31.5/23.8 C377 4550007320 S.TAN F930J226MAABMA B 79.7/17.1
C203 4030019930 S.CER C1005 JB 1A 104K-T B 29.7/24.7 C378 4030019740 S.CER C1005 JB 1H 102K-T B 77.2/17.1
C206 4030011320 S.CER C1005 CH 1H 470J-T B 47.4/16.6 C380 4030011320 S.CER C1005 CH 1H 470J-T B 60.8/11
C208 4030011660 S.CER C1005 CH 1H 020B-T B 37.4/23.5 C381 4030019850 S.CER C1005 JB 1E 183K-T B 68.4/8
C209 4030011660 S.CER C1005 CH 1H 020B-T B 35.4/23.5 C382 4030019850 S.CER C1005 JB 1E 183K-T B 68.4/6.3
C210 4030019650 S.CER C1005 CH 1H 050B-T B 35.4/25.1 C383 4030009800 S.CER C1005 JB 1H 471K-T B 69.3/4.6
S.=Surface mount
6-3
[MAIN-A UNIT]
REF PARTS H/V
NO. NO. DESCRIPTION M.
LOCATION
C391 4030011320 S.CER C1005 CH 1H 470J-T B 37.3/46.3
C393 4520000020 S.NIO NOJC227M006 B 19.8/40.9
C395 4520000020 S.NIO NOJC227M006 T 21.7/37.1
C397 4030019740 S.CER C1005 JB 1H 102K-T T 26/36.5
C398 4030019740 S.CER C1005 JB 1H 102K-T B 12.2/32
C399 4030019930 S.CER C1005 JB 1A 104K-T B 22.2/37.1
C400 4550006250 S.TAN TEESVA 1A 106M8R T 12.9/40.8
C401 4030019930 S.CER C1005 JB 1A 104K-T B 12.2/37.6
C403 4030019930 S.CER C1005 JB 1A 104K-T B 15.8/39.6
C404 4030019930 S.CER C1005 JB 1A 104K-T B 12.2/38.5
C405 4030019970 S.CER C1005 JB 0J 105K-T B 19.3/33.7
C406 4030019740 S.CER C1005 JB 1H 102K-T T 20.7/32.2
C408 4030019930 S.CER C1005 JB 1A 104K-T T 5.2/37.8
C410 4030019740 S.CER C1005 JB 1H 102K-T T 11.3/39.3
C412 4030019740 S.CER C1005 JB 1H 102K-T T 6.5/42.8
C413 4030019740 S.CER C1005 JB 1H 102K-T T 6.8/44.8
C414 4030019740 S.CER C1005 JB 1H 102K-T T 8.1/23.1
C415 4030019740 S.CER C1005 JB 1H 102K-T T 6.5/30.8
C416 4030019740 S.CER C1005 JB 1H 102K-T T 6.1/23.1
C417 4030019740 S.CER C1005 JB 1H 102K-T T 3.7/30.8
C421 4030019930 S.CER C1005 JB 1A 104K-T T 75.4/12
C423 4030019810 S.CER C1005 JB 1E 103K-T B 65.2/38.4
C424 4030019740 S.CER C1005 JB 1H 102K-T T 63.8/34.4
C426 4030019810 S.CER C1005 JB 1E 103K-T B 69/30.3
C427 4030019930 S.CER C1005 JB 1A 104K-T T 73.7/26
C429 4030019810 S.CER C1005 JB 1E 103K-T B 77.2/25.7
C430 4030019930 S.CER C1005 JB 1A 104K-T T 65.9/11.4
C431 4510009870 S.ELE 10 CE 100 LD T 14.7/27.1
C432 4030019740 S.CER C1005 JB 1H 102K-T T 14.3/31.7
C433 4030019930 S.CER C1005 JB 1A 104K-T T 16.2/32.2
C434 4030019810 S.CER C1005 JB 1E 103K-T T 14.3/32.6
C435 4030019740 S.CER C1005 JB 1H 102K-T T 18/32.2
C436 4550007320 S.TAN F930J226MAABMA B 85.2/44.4
C437 4030019930 S.CER C1005 JB 1A 104K-T T 17.1/32.2
C451 4030009790 S.CER C1005 CH 1H 330J-T B 86.6/38.5
C452 4030009740 S.CER C1005 CH 1H 100C-T B 86.1/37.3
C453 4030009770 S.CER C1005 CH 1H 220J-T B 87/35.2
C454 4030019930 S.CER C1005 JB 1A 104K-T B 86.1/32.2
C456 4030019930 S.CER C1005 JB 1A 104K-T B 87.9/32.2
C457 4030019870 S.CER C1005 JB 1A 273K-T B 86.8/46.9
C458 4030019930 S.CER C1005 JB 1A 104K-T T 84.7/45.5
C459 4030019930 S.CER C1005 JB 1A 104K-T B 85.2/40.6
C460 4030019930 S.CER C1005 JB 1A 104K-T B 79.5/46.1
C461 4030019930 S.CER C1005 JB 1A 104K-T B 80.4/46.1
C462 4030019930 S.CER C1005 JB 1A 104K-T B 81.3/46.1
C465 4030019930 S.CER C1005 JB 1A 104K-T T 77.4/35
C466 4030019810 S.CER C1005 JB 1E 103K-T T 79/35
C467 4030019930 S.CER C1005 JB 1A 104K-T B 85.2/32.2
J51 6450000131 CON HSJ1102-018540

J52 6450002250 CON HSJ1456-010320
J53 6510021901 S.CON BM02B-ASRS-TF(LF)(SN) T 30.5/34.5
F51 5210000970 S.FUS ERBSE3R00U T 10.7/37.6
DS51 5040002670 S.LED CL-165HR/YG T 2.6/37.9
MC51 7700002920 MIC EM9745P-38-G-01 <HOR>
S51 2260001900 SWI SW-149 (SKHLLD)

S52 2260002800 S.SWI SW-167 (SKQTLAE010) B 39.2/1.8
S53 2260002800 S.SWI SW-167 (SKQTLAE010) B 48.7/1.8
S54 2250000670 ENC TP70TF5169-15.9F-3285
EP3 6910018460 S.BEA MMZ1005Y102C-T T 63.7/19.3

EP4 6910018460 S.BEA MMZ1005Y102C-T T 41.9/19.4
EP5 6910018460 S.BEA MMZ1005Y102C-T T 41/10.9
EP6 6910014730 S.BEA MPZ2012S331A-T B 22.4/17
EP11 6910021240 S.BEA MMZ1005A152ET T 54.9/24.5
EP14 6910021240 S.BEA MMZ1005A152ET T 60.4/22.2
EP51 6910018460 S.BEA MMZ1005Y102C-T B 20.3/46.6
MP3 8510016471 S.CAS 2775 VCO CASE-1 T 58.8/23.2

MP4 6910014760 S.PLA OG-503040 B 66.8/18.4
MP5 6910014760 S.PLA OG-503040 B 17.9/9.5
S.=Surface mount
6-4
SECTION 7. MECHANICAL PARTS
[CHASSIS PARTS] [ACCESSORIES]

REF ORDER REF ORDER
DESCRIPTION QTY. DESCRIPTION QTY.
NO. NO. NO. NO.
J1 6910021491 ANT CONNECTOR 106-1 1 EP1 (Optional) FA-SC57U-1 1
SP1 2510001560 045P01202-02 1 EP2 (Optional) BP-264 EXP

[USA-11], [USA-12], [EUR-21], [EUR-22], [UK-01],
W1 8900009640 OPC-963 1 [UK-02], [EXP-11], [EXP-12], [EXP-21], [EXP-22],
[EXP-01], [AUS-21], [AUS-22], [RUS-21], [RUS-22] 1
EP1 0910065992 B-7262B 1 (Optional) BP-265 [USA-13], [EUR-23], [UK-03], [EXP-13],
[EXP-23], [EXP-03], [AUS-23], [RUS-23] 1
MP1 8010021710 3285 CHASSIS 1
MP2 8210026010 3285 FRONT PANEL (Incl. MP3–9) 1 EP3 (Optional) BC-191 EXP [USA-11], [EUR-21], [UK-01], [EXP-11],
MP3 8210025830 3285 PTT PANEL 1 [EXP-21], [AUS-21], [RUS-21] 1
MP4 8930080110 3285 PTT BUTTON 1 (Optional) BC-192 EXP [USA-12], [EUR-22], [UK-02], [EXP-12],
MP5 8930080130 3285 PTT RUBBER 1 [EXP-22], [AUS-22], [RUS-22] 1
MP6 8930079890 3285 LOCK PLATE 1 (Optional) BC-193 EXP [USA-13], [EUR-23], [UK-03], [EXP-13],
MP7 8210025800 3285 BOTTOM PANEL 1 [EXP-23], [AUS-23], [RUS-23] 1
MP8 8930080380 3285 SHAFT 1
MP9 8930080180 SP NET (F) 1 EP4 (Optional) BC-123SA (L) [USA-11], [USA-13], [EUR-22],
MP10 8930080170 3285 NAME SHEET 1 [EXP-11], [EXP-13], [EXP-22], [RUS-22] 1
MP11 8930080120 3285 LENS 1 (Optional) BC-147SA [USA-12], [EXP-12] 1
MP12 8930080620 O-RING (CF) 1 (Optional) BC-123SE (L) [EUR-21], [EUR-23], [EXP-21],
MP13 8930080630 3285 SP PLATE 1 [EXP-23], [RUS-21], [RUS-23] 1
MP14 8930042350 1922 MIC SHEET 1 (Optional) BC-123SV (L) [AUS-21], [AUS-23], 1
MP15 8930080410 3285 MIC SPONGE 1 (Optional) BC-147SV [AUS-22] 1
MP16 8930079900 3285 TERMINAL HOLDER 1
MP17 8930080100 3285 PLUS TERMINAL 1 MP1 (Optional) MB-124 1
MP18 8930080400 3285 MINUS TERMINAL 1 MP2 8210025840 3285 JACK PANEL 1
MP19 8930069710 THERMALLY SHEET (BC) 1 MP3 8810004861 SCREW PH M2X6 ZK3 2
MP20 8830003390 VR NUT (AB) 2
MP21 8930080090 3285 SIDE PLATE 1
MP22 8930080150 3285 SIDE SEAL 1
MP23 8930080140 3285 TOP SEAL 1
MP24 8830003440 3285 ANT NUT 1 EP2 EP1
MP25 8610014180 KNOB N-389 (Incl. MP26) 1
MP26 8610007510 KNOB SPRING NO.7800 1
MP27 8610014190 KNOB N-390 1
MP28 8610007920 KNOB SPRING NO.1500 1
MP31 8810008761 SCREW BT B0 2X8 NI-ZC3 (BT) 2
EP3 EP4
MP34 8810009181 0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT) 2
[MAIN-A UNIT]
REF ORDER
NO. NO. DESCRIPTION QTY.
MP1
J51 6450000131 HSJ1102-018540 1
J52 6450002250 HSJ1456-010320 1 MP2
MP3
J53* 6510021901 BM02B-ASRS-TF (LF) (SN) 1
MC51 7700002920 EM9745P-38-G-01 1
S51 2260001900 SW-149 (SKHLLD) 1

S52* 2260002800 SW-167 (SKQT) 1
S53* 2260002800 SW-167 (SKQT) 1
S54 2250000670 TP70TF5169-15.9F-3285 1
MP2 8510016461 2775 VCO COVER-1 1

MP3* 8510016471 2775 VCO CASE-1 1
MP4* 6910014760 OG-503040 1
MP5* 6910014760 OG-503040 1
MP6 8930080760 SPONGE (KT) 1
MP7 8930080770 INSULATION SHEET (MQ) 1
*: Refer to “BOARD LAYOUTS” for the location.

Screw abbreviations A, B0, BT: Self-tapping PH: Pan head ZK: Black NI-ZU: Nickel-Zinc SUS: Stainless
7-1
J1(C) MP23(C)
MP20×2(C)
MP1(C)
MP19(C)
ANT PCB
MP31×2(C)
MP16(C)
MP18(C) MP22(C)
MP33(C)
MAIN UNIT S51(M) MP31×2(C)
S54(M)
MP17(C)
R421(M)
MP32(C)
J52(M)
MP27(C) MC51(M) MP2(M) J51(M)
MP13(C)
MP34×2(C)
MP6(M)
MP25(C)
MP3(C) MP21(C)
MP24(C)
MP11(C)
MP32(C)
MP4(C) MP12(C)
MP34×2(C)
MP5(C)
SP1(C)
W1(C)
MP9(C)
MP15(C)
MP14(C)
MP10(C)
MP2(C)
MP6(C)
MP7(C) MP8(C)
UNIT ABBREVIATIONS
(C): CHASSIS PARTS
(M): MAIN-A UNIT
7-2

SECTION 8.
V0 V5 V10 V15 V20 V25 V30 V35 V40 V45 V50
H0
DS51
C417
Q75
R438
C408
R424
H5
C416
C415
C412
C413
Q76
R423
C414
PWON
(TOP VIEW)
H10
F51
• MAIN-A UNIT
8-1
C410

C400
C432
C434
C431
FUSE
J51
H15
-PDET IC54
C433
C437
C435
BOARD LAYOUTS
R413
H20
C406
AFO
IPTT
C395
-T1
-HV
-AFON
H25
C397
-R5V
RSSI-
R11
J53
H30
C21 R14
R12 C23
IC1 R13 R407
Q6
C20
-T2
[SPEAKER MICROPHONE JACK]
R15 R17
-PAV
H35
C24 R18 R16 C25
C27 C26
J52
T1
C257
C28
D35
R149 R148
-APCV
2
C22 C158 C256
C254
C252
Q26
IC2
L23
C159 R82
H40
EP5 C157
C255
C253
C251
L24
1
C160 X2 EP4
-TMUT
C155
IC2
R135
R136
C232
C239
KEY1-
C152
C150
-T5V
C154
C153
R80
X2
KEY2
H45
R137
D18
R83
R78
R77
C149
C133
C134
C234
X1
X1
C156
C132
R76
C94
Q25
H50
C267
C71
MC51
C90
L31 C73
D12
C85
C84
C87
L36
EP11
C92
Int. SP
Q8
H55
L37
C86
C88
R88
Q13
C89
D11
R41 R42
R54
C81 C74 C83 R53
R89
L41
MP3
L33 C78
D14
C101 R55
R364
C344
-TEMP
R56
EP14 C104 C107
H60
FI2
L42
Q10
R368 R369 C111
R57
C106
D16
Q14
C310 R313
C110
R46 C304
REF
BAL
R45
FI3
EP3 R87 C307 R314 R315

C424
L40
R64
C102
C103
C105
C108
C77 R311 R312
CL-
D15 C306 C308

Q51
H65
-VCON
C430
CPU5-
R401
R310
R317
IC62
R318 C309 R316
PLST
-CDEC
VREF
DISC-
SDEC
IC62
R469 R468
H70
R383 R381
R5C
S5V
DISC
-SCK
-SO
R352 R382 C326 Q82 Q83

MOD-
R463
R353 C331 C330 C328 R325

BAL-
+5V
C332 C371 R386 R387 R464 TLED

R355 C427 R321 R326
-VOXV
R371 C333 R385 R391 C373
RMUT2
C329 C314 C312
R330
RLED-
MMUT
R354 C421 C372 R351 R328 R327 Q52 -ADSW -NOIS
H75
-UNLK
C305
C313
R331
C316
C465
-RMUR1
R329
MMUT
C466
C346
IC58
R420
-ATX
R372 IC58 IC56 IC59 I C6 1
H80
IC56
R457
R384
-EPTT
C348
AFON-
IC61
C347 C358 R348

LVIN
IC59
R439 C357 R349

BATV
R373 R377 R379 C323 R343 R342 R341
C354
C458
C349 R375 C351
H85
R346 R345 C322 C321
R374 C352 C350 R378 R350 C324 R344
X51
C325
X51
-TMUT
H90
UHF B7247B
The combination of top side and bottom side of this
The combination of top side and bottom side of this
J52 J51
• MAIN-A UNIT
(BOTTOM VIEW)
V50
CPU5-
R472
C457
EP51 C334
R473 R474 C391 R408
C462
C461
C460
R476
R470
-CL
Q81
D51
V45
R471 R406
IC53
C436
R128 C226
Q85
Q84
C335
R361
R146
R441
R440
IC3
C236
C235 [VOLUME CONTROL]
Q24
R456
IC55
IC55
R147
C231 C227
C263
-RES C393
C262
R126 R127 R125

C459
D33 D31
V40
C238
PWON R134
R466
R155 C225 C228
C403
D34
R151
IC3
C233
R153
C451 C423 C261 C404

IC51
R412
R418
C401
PWON
C452
R451
R467
C399
R417
C244
C265
R154
D32
Q71
Q27
R158
C264 R416 Q64 Q63
V35
R139 C243 C240 R138
R453
C453
R455
R81
C266 R152
NWC -RSSI R414
R437
FI1
R431
R477
Q74
C242 R140 C220
D21
R442
C405
D52 Q19 R141
R102
D55
R324
R323
R322
R143 C241
C456
R454
C454
C467
C398
R101
C120
R142
R70
Q21
-SQIN
C188
R109
R107
C186
R461 R432 R103
C124
V30
R73
Q72
C426
R433
R460
C127
R458
R459
R475
R436
R434
R68
C109
R462 R123 C218

Q17
R71
R119
R116
C93
Q22
R108
R106
C181
C91
+5V C197
C318
C363
R403
LVA
C200
C198
C196
R113
C195
C356 L14
L20
R72 C123
C116
C117
C215
R121
L16
L15
R63
[ROTARY SELECTOR]
Q23
C192 C194 R105

L35
-REF
C199
R115
D28 R114 D26 C180

IC52
C184
R66
R65
C429 C179
V25
IC52
Q11
R112 C189 R110 C183
C178
R122
C221
C216
C217
R120
C213
C214
R118
C210
R117
R157
R51
L19
C118
IC57
C203 C177
R435
Q73 Q12 C201 R159 D24 C176

C223
C208
C209
C212
C80
L18
-R5V C182
R402
L13
C361
R52
T1- R156 R104
C175
V20
C141
L32
L47
C362
MOD-
C121
Q9 C147
C19
C18
D22
C142
C173
R44
C76
C82
R43
MP4
S5V R6
R132 C224
C377
EP6
C378 C72 C172
L11
D6
L4
R35 C206
+5V
C79
R67
Q15
C37
C36
C171
S5V- C9
R347
V15
R390
D5 C63 R32 R30 C38
-VREF D3
C122
C8 C5
Q2
-TEMP
C302
C51
IC60 C65 R34 C59 C39

R388
R389
C376
DISC- L6 L3
Q1
Q4
L7
L5
C11
C10
R33 L48
Q3
C301
R301
R303
R302
C55
C64 C45
C61 C62 C13 C12
C380
R370
SDEC- R5
R304
C303
R26
C57
R21
L9 C53 L8
D2
V10
L2
C14
C340 R359
C4
R31 C54 R29 C6
R366 R360 MP5
R398
C364
R27
C29
R22
C47
R23
C60 C52 R4 R2
MMUT- R363 C336
C381
APCV R3 C3
R393
R395
IC60 -VCON L1
C339
R362
C338
C337
C343
Q59
Q58
-EPTT TMUT- PDET-
C7
D1
R426
C382
C342
R396
R394
-ATX
C2
C1
R1
V5
C383
R427
C365
R397
C385
S53 S52 C388
R430 R429 R428
C390
C389
D53
S53 S52
V0
H90 H85 H80 H75 H70 H65 H60 H55 H50 H45 H40 H35 H30 H25 H20 H15 H10 H5 H0
[LOWER KEY] [UPPER KEY] [PTT SWITCH]
MC51
8-2

SECTION 9. BLOCK DIAGRAM
S5V
400-470MHz
Q17 Q15
2SK880 2SC4116 Q11:LDTC144EE
LVIN RIPPLE VCO R5V

BUFF FIL SW
D11
HVD376B RX VCO
Q13:2SC4226
15.3MHz LV D12:HVD350B
IC60 X2 ADJ Q10 Q8 D5:HVD142A Q4 Q3 Q2 Q1 D3:HVD142A
NJM12902 CR-794 2SC5107 2SC5107 D6:HVD142A 2SC5107 2SC3356 RD01MUS1 RD07MUS2B D 22:HVD142A
BAL
VCON LOOP LV TX/RX PRE PRE DRIVE PWR ANT
BUFF TCXO BUFF BUFF DRIVE LPF LPF
REF FIL D14 SW AM P AM P AM P SW
HVD376B TX VCO
LVA LV
Q26 IC2 ADJ Q14:2SC4226 Q9 Q21 IC1
2SC4116 M B15A02 D16:HVD350B 2SC5107 2SK1829 TA75S01F
PLL RSSI AGC APC PWR D1:RB886CS

X3 LPF BUFF LPF 353.65 MHz-423.65 MHz D2:RB886CS
IC D15 CTRL AMP T1 DET
1SV309 Q12:LDTC144EE
FM VCO R5C
MOD SW Q24 FI1 D28 D28 D26 D24 Q6
2SC4215 FL-442 Q23 HVB350B HVB350B HVB350B HVB350B LDTA144EE
46.35MHz 3SK293
BPF 45.9MHz IF IC IF XTAL
BPF BPF
RF
BPF BPF MUTE TMUT
AM P BPF AM P SW
IC3:NJM2591
Q22
MIXER 3SK293
D31:D32 FI2
1SS390 LTM450GW T2 T1
Q25
W/N CERAMIC LDTC144EE
D/A SW BPF
X1
SQIN W/N
FI3 450kHz RSSI NOIS SW
R133
VOL1
LTM450HW JTBM450CX70
DISC CERAMIC W/N
BPF SW D33,D34:1SS390 RMUT 1
Q27:LDTA144EE
REF,LVA 450kHz
T1,T2 NWC IC59 IC58 IC62 J51
LM2902 Q58:UNR911HG0
NJM12902 CD4066
R132 RX EPTT PTT

LPF HPF
MUT E DET
IC58 IC56 RMUT 1
VOL1 NJM12902 CD4066 S1 MMUT
Splatter MC51
LPF S2
SW12
IC58 IC58 IC62 IC60
NJM12902 NJM12902 CD4066 NLM12902 Q59:LDTC144EE EM9745P
SW12
MMUT
R133
VOL1
ANALOG MIC ATX AUTO_TX

AM P HPF AM P
SW MUTE CTRL
S3 RMUT 2
MGC0
S4 IC62 MIC_GAIN
SW12
AFO IC60 CD4066 CTRL MGC1
D 53:L1SS400
T5V NLM12902
SW12
R132
CTCSS/DTCS VOXV AMP IC55 TPA0211DGN
DET
VOL1 MOD
RBEEP TBEEP AFO AF J52

AM P
IC52
R1EX24016
J53
IC59
LM2902 EEPROM 1 SP1
AF
2
IC57 AM P
LPF
R2A20178 AFON
T5C
IC61
CD4053
IC60
NJM12902 IC61:CD4053 BEEP BEEP Q63:2SB1132
SW Q64:XP6501
BEEP SENC SDEC AFON
LPF
SW R88 PWR
TEMP VCC CTRL
Q73
AF VOL KTA2015
Q51 T5C
CTCSS/DTCS DEC XP4601 CPU AFVI T5 T5V
R1
REG D51:LRB706F
DISC Q81:UNR9210G0
LPF
Q74:2SB1132 Q72
CDEC Q75:XP6501 2SA1586 CLONE
IC51 PTT
Q76:LDTC144EE R5C BUFF
IPTT PWON R5 R5V
IC59 +5V REG
PUSH1
LM2902 F1 VCC REG
CENC0-2 P1 Q71
LPF R4F20102 KEY1 KTA2015
P2
PUSH1
KEY2 S5 S5V
S5C REG
PUSH1
F2
Q52 S54
LDTC144EE TP70TF5169 +5V
IC53 IC54
DUSE FIL N JU7704 NJM2871
SW SELECT
RES RESET CPU5 CPU5
REG
CSFT CPU5
D52 Q82:Q83 S5 F51
X51
1SS390 LDTA144EE YG VCC 12
CR-864
SW12
SHIFT ERBSE3R00U
BT1
BATTERY_1
SW CTRL
12.288MHz HR
DS51
CL-165HR
9-1

SECTION 10. VOLTAGE DIAGRAM
MAIN-A UNIT (1/2)
DISC
R303
SQIN
T2
T1
SCK
LVA
+5V
DAST
SO
MOD
56k
C303
220P
IC60
C301 R301 R302
DISC 6
1.5k
0.1 15k 12k
5
B 7 SDEC
C361
R304
470
R402
0.018
0.047
100k
0.1
R394
C302
C305
HV
1k
NJM12902V HV
R401
R403
0
VREF +5V
+5V
C TCSS/DTCS FILTER R314
C362
S5V IC57 R2A20178 S5V
0.1
R393 R396 C365 S5V
6
5
4
3
2
1
R313 390k REF
C304 R5V
R315
82k
47P
DI
VIN3
CLK
LD
VDD
VIN2
C310
270k 270k R5V
0.01
25
C318
120k
R395
0.1
3.3k 10 R397
T5V
C363
C307 0.1 7 T5V
24
0.1
R321 VOUT3 VOUT2 180k
4 3 S5V 8 23 R5C
R310 R311 R312 VOUT4 VOUT1 IC60 R5C
DISC 9 22
15k VIN4 VIN1
5 2 10 21 13 SO
0.039
0.0068
R351 22k 22k 22k R316 R322 VIN5 VIN8 SO

11 20
CENC0 D 14 VCON
C306
C308
VOUT5 VOUT8 R398

6 1 12 19 BAL 12 SCK
18k 470 180k VOUT6 VOUT7
0.0047
SCK
VDAREF1
VDAREF2
C364
C313
C329 R323 10k
RESET
Q51 CENC1 IC59 PLST
0.1
VIN6
VIN7
R317 R318 PLST
XP4601 2
GND
0.0047 CDEC 56k R329 NJM12902V
1 C356
C328 R355 IC59 6.8k 10k R324 R326 R327 R328 A NWC
NW C
0.022
6 CENC2 3 10
13
14
15
16
17
18
C309
C330 C331 C333 4.7k

B 7 TMUT
0.0012
1 10k 22k 47k 47k 47k TMUT

0.018
5 LM2902PWR +5V
6.8k
R325
R331
0.01 0.01 0.0047
C312
C314
C316
1M
47k
NJM12902V MOD
0.1
8.2k
6.8k
R352
R353
R354
R371
MOD
0.001
10k
C378
LM2902PWR C332 6 IC58 Q52 VCON
1.5k
R390
VCON
VREF
0.0047
5
B 7
SQIN
LDTC144EE SQIN
VREF
IC62 DUS E LVA
C377
22
LVA
0.001
+5V +5V 14 1
R388
R389
C376
VDD I/O1
12k
RMUT 1 13 2 T1
100k
R330
R381 R385
1k
CONT1 O /I1 T1
12 3
CONT4 O /I2
0.001
11 4 IC59 IC59 T2
C322
C324
0.01
I/O4 I/O 2 270k 120k T2

10 5 M MUT 13 9
R382
180P
C372
O/I4 CONT2 C326
0.001
9 6 R341 R342 D 14 R344 C 8 R386

C335
O/I3 CONT3 R343 12 R345 10 IC58

8 7 SENC 0.01 2
R387
C448
I/O3 VSS 470k

A 1 LVIN
0.0047
68k 68k 68k 68k 68k R383 LVIN
10
J51 CD4066BPWR LM2902PWR LM2902PWR 33k 3

R350
R361
390P
C321
C323
C325
C371
1.5k
0.001
0.047
10k
47P
TEMP
2.2k
R346
R391
C373
C380 560k TEMP
47k
470
47P R374 R384 NJM12902V RSSI
C347 RSSI
R370 RX
0.001
C336
D ISC
1
EP51
82k
0.01
C334
3.9k 100k DISC

TX
IC56
R373
C352
C354
470k
MMZ1005Y102CT IC60 1 14 NOIS
0.1
0.1
C379
47 MSVB2
2.2k
R439
R366 R368 R369 C346 C348 IC58 I/O1 VDD NOIS

2 9 2 13
R377 O /I1 CONT1
0.01
C357
C358
150k 270k 150k
3
A 1 0.039 0.039
10
C 8
C349 R375 R379 3
4
O /I2 CONT4
12
11
UNLK
UNLK
5.6k
R372
0.1
C340
33k I/O2 I/O4

MC51 5 10
0.1
R359 NJM12902V 0.1 470 C350 270k CONT2 O/I4

6 9
100k
R348
R349
NJM12902V CONT3 O/I3
7 8
R378
0.0012
C351
220P
1M
8.2k VSS I/O3
0.001
10k
VREF VREF IC58

R362
R347
C337
33k
10k
13 CD4066BPWR
2.2k
R360
EM9745P
VREF 12
D 14
RMUT 2
RMUT 1
TBEEP
RBEEP
R363 R428 R429
0.001
MMUT
VREF
VREF
C338
T5V
+5V
NJM12902V
AFO
C343
10
470 1.5k 390k

9 IC60
Q58 D53
8 Q71
UNR911HG0 C381 C382 10
C VOXV
S5V
NJM12902V
IC58
LM2902PWR
IC59
KTA2015
L1SS400
4 4
RSSI
AFVI
LVIN
TBEEP
0.018 0.018
0.1
0.1
RBEEP
BEEP
NOIS
T5C
BATV
STONE
SENC
SDEC
CL
CPU5
RMUT 2
TEMP
UNLK
C421
C427
VOXV
RMUT1
TMUT
V+ V+
MMUT
R430
470P
C383
C385
NJM12902V
0.001
GND GND
0.1
100k
330k
R364
R426
R427
C423 R431
C339
C344
1M
R473 100k
15k
0.01 10k
11 11
0.1
R432
S5C
LRB706F
16
15
14
13
12
11
10
C465
SW-149 4.7k
9
CPU5 CPU5
0.1
D51
100k
R470
Q59 EPTT EPTT UNR9210G0
X1
X0
Y
B
1k
X
LDTC144EE
C
A
2SA1586
VDD
Q81
CD4053B
ATX ATX
R476
S51
0.001
R5V Q72 CLO
IC61
C388
0.001
C342
C460
INH
VEE
VSS
0.001
Q84 Q85 0.1
Y1
Y0
Z1
Z0
R440 R471
C424
Z
LDTC144EE LDTC144EE AFON
C426 R433
C461
0.01 10k
R434 0.1
1
2
3
4
5
6
7
8
390 15k
R5C R474
C462 R472
R441 10k 0.1
+5V 100k 15k
0.001
S52
SW-167
C389
10k KTA2015
IPTT IPTT
T5V Q73 ADSW
KEY1 KEY1
LDTA144EE
KEY2 KEY2
C429 R435
Q82
0.01 10k
R436 R469 DS51

CL CL T5C RLED YG
0.001
S53
SW-167
55
54
53
52
51
50
49
64
63
62
61
60
59
58
57
56
R412
C390
C403 4.7k 390

IC55 AFO
C391
Q83
8 1
47P
P24/TRDOI_0
R408
0.1
P13/IRQ3
P12/IRQ2
P11/IRQ1
VO- IN 4.7k R468

P27/TXD_2
PB3/AN 3
PB5/AN 5
PB4/AN 4
PB0/AN 0
PB1/AN 1
PB2/AN 2
P26/RXD_2
100
7 2 R413 100k AFON TLED HR

PA7
PA6
PA5
PA4
GND SHUTDOWN NJM12902V

6 3 +5V CL-165HR
C393 SE/BTL VDD 1.8k
5 4 IC60 CDEC
C400
10 MSVA
VO+ BYPASS LDTA144EE

4 STONE MGC1
100k
R420
C401
220 V+
J52 TPA0211DGN RES MGC0
0.1
9
C404
C430
GND 1 48
0.1
0.1
PB6/AN6/DA0 P25/SCK3_2
11 IC53 2 P23/TRCOI 47 R466
C395
220
PB7/AN7/DA1
1 5 CPU5 3 P22/TXD 46 R467
Q63 CD VDD AVCC
2SB1132 VCC 2 4 P21/RXD 45
VSS X2
0.001
0.027
3 4 5 P20/SCK3 44
C431
100
R442
C398
C457
D55 2SB1132 MR VOUT X1

0.001
6 43
100k
IC51 100k
R423
P87/TREO
C432
AVSS
Q74 NJU7704F3 7 R4F20102NFA P86/TRBO 42
R416
R456
C458
330 L1SS400 10k RES

8 41 100k DUS E
0.1
XP6501 R414 TEST P85/TRAIO

BATV 9 P67/FTIOD1 40 CBI3
1k
R451 VSS
10 P66/FTIOC1 39 CBI2
R405
R437
Q64 330k PJ1/OSC2

0.001
10k
4
10
1.8
11 P65/FTIOB1 38 CBI1
100k
R424
C405
C406
C408
J53 PJ0/OSC1
CR-864 12 37 CBI0
0.1
R454 P64/FTIOA1
C433
C453 VCC
X51 CSFT 13 36 CENC0
0.1
P60/FTIOA0
1
3
1 P37/TXD_3
22P 14 NMI 35
C456
2 Q75 22k P36_RXD_3

1SS390
4
XP6501 15 34 CENC1
0.1
P61/FTIOB0
100k
R406
P35/SCK3_3
0.001
IC54 16 P62/FTIOC0 33 CENC2

D52
R453
3
1
C397
P34/FTCI
12k
1 5
P56/SDA/SCS
P57/SCL/SSI
CTRL VIN R455 R463

P63/FTIOD0
2
P33/FTIOD
P32/FTIOC
P31/FTIOB
P30/FTIOA
P53/TGIOB
P51/TCLKB
P50/TCLKA
P52/TGIOA
GND
P15/IRQ5
P16/IRQ6
P17/IRQ7
P55/SSCK
3 4
R417
R418
C399
NB VOUT 10k
P54/SSO
12k
15k
RLED
TLED
OPT2
OPT1
0.1
C436
22
C451
C452
C454
1k
NMI
33P
10P
NJM2871BF05
0.1
1
0.01
C434
+5V
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
CP5 F51 IPTT

2.2k
R438
R421
CP06S 12 HV
100k
CPU5 CPU5
0.001
ERBSE3R00U
C410
R464
0.001
ESCL
ESDA
C435
C437
AFVI
0.1
4.7k
4.7k
R461
R462
C459
IC52
0.1
R477 1k
0.001
0.001
8 1
C413
C412
VCC A0
Q76 7 2
4.7k
R457
WP A1
S54 PWON 6 3
TP76N00N SCL A2
2 1 5 4
1k
1k
C1 A1 SDA VSS
3 CBI0 LDTC144EE CP05S R460
100k
R475
B1 CP6
5 4 CBI3 CP05S R1EX24016ATA00A
C2 A2 CP7
6 CBI2 CP05S
C467
C466
0.01
B2 CP8
8 7 CBI1 CP05S
0.1
C3 A3 CP9
R458
R459
9 CP05S
B3 CP10
0.001
0.001
0.001
0.001
CP05S
C414
C415
C416
C417
CP12
TP70TF5169 CP05S 100k
CP11
OPT2
OPT1
DUSE
EPTT
BEEP
AFON
KEY2
KEY1
PLST
DAST
PWON
RES
NMI
NWC
ATX
SCK
R5C
T5C
S5C
SO
*: Refer to the PARTS LIST for the value and name of component.
10 - 1

T2
T1
SO
HV
LVA
MOD
NWC
SCK
R5C
T5V
R5V
S5V
+5V
UNLK
NOIS
DISC
RSSI
TEMP
LVIN
SQIN
VCON
TMUT
PLST
MOD
NWC
VCON
TMUT
HV
SO
UNLK
TEMP
+5V
LVA
R5C
T2
T1
SCK
R5V
T5V
S5V
NOIS
SQIN
PLST
DISC
LVIN
RSSI
SO
HV
+5V
S5V
SCK
S5V
+5V
S5V
T5V
VCON
PLST
UNLK
TEMP
LVIN
C160
MAIN-A UNIT (2/2)

0.001 C156
EP5
R89 C159 0.1 C152 CP1 0.001
1k
R78
C155
100k 0.1 0.001 C123
2
1
CP06S
L1SS400
47P R81
R88
X2
C154 C124
MOD
GND
MMZ1005Y102C T
150k
VCON
100
R72
47P 0.001
D18
CR-794
C153
C118 R73
47P C134 C133
ERTJ0EP473J
OUT
47P 4.7k
VCC
R80
EP4
C150 1 SVA 0.047
3
4
R66
1k
Q17
R82
150k
R70
120k
0.001 R71 R77
10k R65
16
15
14
13
12
11
10
2SK880
10k
9
3.9k
C158 C157 27k C120
B
P
1k
NC
FC
R76
LE
10P 0.01 0.001
1k
C122
FOUT
DATA
C132
R158
CLOCK
MMZ1005Y102CT
R68
NWC R155 WNC 0.01
470k
0.47 SVA
C121 R67
Q27
IC2
27k
PLL
C116 C93
MB15A02PFV1
OSCIN
OSCOUT
VCC
GND
FIN
VP
DO
LD
10 2.2k
1 330P
D34
D33
1
2
3
4
5
6
7
8
1SS390
1SS390
R154
Q19
C94
LDTC144EE
C127
LDTA144EE
8.2k 47P
Q15
R153 0.0015
1U
1U
C267
L42
L37
0.1
C149
3.3k
2SC4116
C117
0.001
LVA
0.01
C263
D16 D12
10P
0.0022
C256
0.01
C265
R83
33P
C107
HVD350B HVD350B
56
C89
I
O
R63
R87
22k

C111
100k
FI2
FI3
20P
R149 R148
C92
24P
R5V
O
D15
D14
C266 R64 C110
I
680k 1k
LTM450GW
LTM450HW
D11
L41
L35
33P HVD376B
10
HVD376B
1U
0.01 1SV309 0.5P
2SC4116
0.47U
Q26
C264
0.01
L24 C257
R152 R5C
0.01
C262
WNC C91
0.18U 0.01
8.2k C254 C255 1
L40 L36
D32
D31
C109
6P
56P 0.01
5.8N
1SS390
1SS390
R151 MP4 0.001
C253
0.30-0.9
C252 O G-503040 C108 C90
27k
0.1
56P 5P 1.5P
C261
X3 MULTI
R56
15P
18P
C88
C106
6.8k
L23
R54
C244 C105 C104
6 .8k
C87 C86
0.1 0.18U C147 9P 4P
18P 7P
R147 R146 7P
R57
Q13
3P
R53
C251
1
6.8k
R55
MP 3
2
6.8k
1.5k
4.7
R139
100k
47 3
R140 C242
C243
180P
4
C85
2775
3.9k 180P
8
7
6
5
4
3
2
1
HV
TX VCO
RX VCO
0.001
MMZ1005A152ET
S5V
T5V
2SC4226
47k
L47
18N
VCOV
V+
Q14
R141
EP14 C103 C84
DEC
IFIN
OSCIN
FILIN
R143 R142 0.001 330P
2SC4226
FILOUT
MIXOUT
OSCOUT
MMZ1005Y102C T
C102
560
IC3
4.7k 100k
0.1 EP3
R52
SQIN C241
R51 EP11
47P
NJM2591V
C142
C236 680
C101
0.5P
QUAD
GND
7P
AFOUT
IFOUT
C240 C79
RSSI
MIXIN
IF IC
NOISEREC
NOISEDET
0.001
0.75P
C83
9
0.001 R138 0.1
10
11
12
13
14
15
16
MMZ1005A152ET
DISC
C80
470 R46 R45
RSSI
Q11
330P
R5V
R5C
Q10
Q12 LDTC144EE
C239 C238 C235 100k 100
R5C
2SC5107
LDTC144EE
L33 C77
R5V
330P 0.001 10
R134 22N 0.001
NOIS
C81 C78
C233 100k
R135 3P 0.001
5P
0.001 C82 C73

C74
2.2k
47P 0.001
22P
R42
C232
100P
C231
R136
2.2k
0.001 C72
R137 X1 C76 68k 0.001

Q8
2SC5107
R44 L31 R41
Q9
3.9k
JTBM450CX70 100k 33N 10
Q24
2SC5107
R128 R126 R43
0.01
C234
L32
6P
33N
C141
680 2.2k 100
R127 C225
10P
C71
Q25
IF AMP
100k 0.01
2SC4215
C226
NWC 0.01
0.01 560
C228 R132 D6 0.001
C227 R125
0.5P 10k C65
LDTC144EE
HVD142A
HVD142A
C224 R35 R34 R33
2
4
100
5P
C217 R122 0.001 4.7k 10k C64

D5 C63
OUT
GND
FL-442
C220 0.01 47 R32 R31 0.001
6 5 C216
7P 22k 100
GND
0.001 L9 C60
IN
47P
C206
C221 C223
FI1
3
1
18N 47P
Q4
47P 0.001 C62

C218 R123 L20
HV
8P
T5V
2SC5107
0.01 10 0.56U C61

C215
0.001
5P
C59
18P R30 R29
Q23
R120 R121 C208
22k 47
120 3.3k 2P
MIX
L8 C52
C214 R119 C57
12N 0.001
Q3
2SC3356
10P
C55
0.001 330P
39N
150k
L18
3SK293
R27 R26
R118
120k
C213 C209 C29 C54
R117
47P 2P 0.001 4.7k 47 0.001
R116 100k C51 C53
120k 4P 330P
5P
15P
C210
Q2
C200
C28
R23
RD01MUS 1
C199 C212 L48 EP6

1
2.5P 0.001 33k 1.0N
L19
56N
L16 C39
C47
12N 47P
APCV
R115 C198 330P C38

47P
C45
100k 12P C27 R22 R21 10 0.001

M PZ2012S331A
C203 1 4 C37
0.001 4.7k
D28
0.1 330P
0.5P
C197
C201 2 3
R159 R18
R5V
C36
0.001
HVB350BYPT L
R157 6.8k R114 C196 C192 1k C26 47P
T2
PAV
Q1
L7
R17
270
1k 100k 12P 0.001 0.001

C195 R113 C189 18.3N
RD07MUS2B
C25 0.01 R16

2.5P 3.3k 0.001
R110 L15 R112 10
L6
10 - 2
C14 C18
RF AMP
100 47
4
12N
Q22
2.8N
IC1
22P 0.001
APC
R108
TA75S01F
C194 C13
3SK293
C24
2
5
D35
470k
R15
0.001 82k 15P

L5
C19
R109
L1SS400
1
3
2.8N
0.22
R14 C12 0.001

10
0.1
10k
Q6
8P
C186
R106 120k
R107
C188
47k 0.001 C23 L4 R6

0.001
C11
R12
10k
L14 0.1 0.82U 220

T5V
C180
7P
C181
1 4
D3
27P 22N
H VB350BYPTL
2 3
LDTA144EE
AGC
HVD142A
R13
Q21
R103
100k
C179
D26
R156 6P 1.8k
10k
R105
T1
C20 C22 C9
0.001
C10
1k C177
2P
C178
0.001 C183 0.001 0.001 4P

2SK1829
6P
L3
10k
R104
C182 0.001 1 4
D21 R102
10.3N
C184 C176 L13

C8
2 3
2.5P
L1SS400 470k D2 C6 R5
0.1 27P 22N
RB886CS 0.5P 2.7k
D24
R11 C5
47P
C175
C4
R4
1k
8P
1.5P
2.7k
L2
R101
220k
LPF
C7
13.6N
0.001
HVB350BYPTL
C21
0.001
C173
C2
0.001
D22
1k
R3
8P
R2
L1
HVD142A D1 C3
C172
13.6N
RB886CS 0.5P 2.7k

2P
L11
22N
C171
C1
4P
1.5P
TMUT
T1
T5V
O G-503040 R1
R SSI
MP 5 68k
ANT_BOARD
*: Refer to the PARTS LIST for the value and name of component.
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
Phone : +81 (06) 6793 5302
Fax : +81 (06) 6793 0013
URL : http://www.icom.co.jp/world/index.html
<Corporate Headquarters> Communication Equipment

2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A. Auf der Krautweide 24
Phone : +1 (425) 454-8155 Fax : +1 (425) 454-1509 65812 Bad Soden am Taunus, Germany
URL : http://www.icomamerica.com Phone : +49 (6196) 76685-0 Fax : +49 (6196) 76685-50
E-mail : [email protected] URL : http://www.icomeurope.com
<Customer Service> E-mail : [email protected]
Phone : +1 (425) 454-7619
Ctra. Rubi, No. 88 Bajos A 08174, Sant Cugat del Valles, Barcelona, Spain
Glenwood Centre #150-6165
Phone : +34 (93) 590 26 70 Fax : +34 (93) 589 04 46
Highway 17 Delta, B.C., V4K 5B8, Canada
URL : http://www.icomspain.com
Phone : +1 (604) 952-4266 Fax : +1 (604) 952-0090
E-mail : [email protected]
URL : http://www.icomcanada.com
Blacksole House, Altira Park, Herne Bay, Kent CT6 6GZ, UK

Unit 1 / 103 Garden Road, Clayton VIC 3168 Australia Phone : +44 (01227) 741741 Fax : +44 (01227) 741742
Phone : +61 (03) 9549-7500 Fax : +61 (03) 9549-7505 URL : http://www.icomuk.co.uk
URL : http://www.icom.net.au E-mail : [email protected]
Zac de la Plaine
146A Harris Road, East Tamaki, 1 Rue Brindejonc des Moulinais BP 5804
Auckland, New Zealand 31505 Toulouse Cedex, France
Phone : +64 (09) 274 4062 Fax : +64 (09) 274 4708 Phone : +33 (5) 61 36 03 03 Fax : +33 (5) 61 36 03 00
URL : http://www.icom.co.nz URL : http://www.icom-france.com
E-mail : [email protected] E-mail : [email protected]
6F No.68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.

10C07, Long silver Mansion, No.88, Yong Ding Phone : +886 (02) 2559 1899 Fax : +886 (02) 2559 1874
Road, Haidian District, Beijing, 100039, China URL : http://www.asia-icom.com
Phone : +86 (010) 5889 5391/5392/5393 E-mail : [email protected]
Fax : +86 (010) 5889 5395
URL : http://www.bjicom.com
81-850 Sopot, ul. 3 Maja 54, Poland
Phone : +48 (58) 550 7135 Fax : +48 (58) 551 0484

1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan S-14617XZ-C1
© 2009 Icom Inc.

Icom IC-F4001 Service Manual

Uploaded by

Copyright:

Available Formats

Icom IC-F4001 Service Manual

Uploaded by

Document Information

Original Description:

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Icom IC-F4001 Service Manual

Uploaded by

Copyright:

Available Formats

UHF TRANSCEIVERS

Downloaded from www.dlmanuals.com

To upgrade quality, any electrical or mechanical parts

ORDERING PARTS REPAIR NOTES

1. Make sure that the problem is internal before

Downloaded from www.dlmanuals.com

SECTION 2 INSIDE VIEWS

SECTION 3 DISASSEMBLY INSTRUCTION

SECTION 4 CIRCUIT DESCRIPITON

SECTION 5 ADJUSTMENT PROCEDURES

SECTION 6 PARTS LIST

SECTION 7 MECHANICAL PARTS

SECTION 8 BOARD LAYOUTS

SECTION 9 BLOCK DIAGRAM

SECTION 10 VOLTAGE DIAGRAM

Downloaded from www.dlmanuals.com

Specifications are measured in accordance with TIA/EIA-603B or EN 300 086

+5V LINE REGULATOR

+5V LINE REGULATOR

CPU5 LINE REGULATOR

2ND IF BPF (For narrow mode only)

+5V LINE REGULATOR

1. REMOVING THE CHASSIS

ANT CONNECTOR NUT

5) Remove the seals and nuts from the CHASSIS.

2) Remove 2 screws from the bottom of the CHASSIS.

BE CAREFUL to not pull out the speaker wire when

2. REMOVING THE MAIN UNIT

For easy separation of the CHASSIS

Suction lifter SCREWS×9

(Continued to the right above)

4-1 RECEIVER CIRCUITS

To the 1st IF circuits RF

1ST IF CIRCUITS Q26

The RX signal from the RF circuits is applied to the 1st IF X3

FI1 To the RX AF circuits

From the TX AF circuits

To the RX circuits MUTE

4-4 VOLTAGE BLOCK DIAGRAM

Tone signal (CTCSS/DTCS) A/D conversion select.

3-conductor 3.5(d) mm plug OPC-478/U/UC

Frequency To [SP] connector

CONVENIENT: The same cloning file is available.

For [EUR] versions:

If the below window appears, the utility is password-protected.

• I/O Check window

*** Lock voltage

(The values shown above are example only.

FM DEVIATION 1 • CH. :8 • Connect a modulation analyzer to the ±2.05 to ±2.15

*; [EUR] versions only

[MAIN-A UNIT] [MAIN-A UNIT]

J51 6450000131 CON HSJ1102-018540

F51 5210000970 S.FUS ERBSE3R00U T 10.7/37.6

DS51 5040002670 S.LED CL-165HR/YG T 2.6/37.9

MC51 7700002920 MIC EM9745P-38-G-01 <HOR>

S51 2260001900 SWI SW-149 (SKHLLD)

EP3 6910018460 S.BEA MMZ1005Y102C-T T 63.7/19.3

MP3 8510016471 S.CAS 2775 VCO CASE-1 T 58.8/23.2