Mazda 6 Technical Training Mps Supplement

Mazda 6 Technical Training Mps Supplement
Full download: http://manualplace.com/download/mazda-6-technical-training-mps-supplement/
TRAINING MANUAL
Mazda6 MPS Supplement
This is the cut pages sample. Download all 112 page(s) at: ManualPlace.com
No part of this hardcopy may be reproduced in any form without prior permission of
Mazda Motor Europe GmbH.
The illustrations, technical information, data and descriptive text in this issue, to the best
of our knowledge, were correct at the time of going to print.
No liability can be accepted for any inaccuracies or omissions in this publication,

although every possible care has been taken to make it as complete and accurate as
possible.
© 2005
Mazda Motor Europe GmbH
Training Services
Contents
Title Section
General Information 00
Engine 01
Driveline/Axle 03
Service Training Mazda6 MPS Supplement

Service Training Mazda6 MPS Supplement
00
General Information
00 General Information
VIN (Vehicle Identification Number) Code.........................................................1

Applicable VIN ................................................................................................1
Engine / Transaxle Combinations......................................................................2
Scheduled Maintenance .....................................................................................3
Features ...............................................................................................................5
Body .....................................................................................................................6
Table of Contents 00 Service Training Mazda6 MPS Supplement

General Information
VIN (Vehicle Identification Number) Code

JMZ GG 8 2 L 6 0 1 600001
Serial No.
Plant 0 = Hiroshima, 1 = Hofu
Dummy 0,6 to 9, A to Z
Transmission 6 = 6MTX
Engine Type L = 2.3L (L3 Turbo)
Body style 2 = 4SD
Remarks 8 = 4WD
Vehicle type GG = Mazda6 MPS, Mazda6 (4SD, 5HB)
World manufacturer indication JMZ = Mazda (Europe)
M6-MPS_00T001
Applicable VIN
European specs:
JMZGG82L60# 600001—
Service Training Mazda6 MPS Supplement 00-1

General Information
Engine / Transaxle Combinations

• The Mazda6 MPS (Mazda Performance Series) fitted with the L3 Turbo engine is
available in Europe exclusively with the A26MX-R transaxle.
• Power and torque output of the L3 Turbo engine are significantly increased in
comparison to the standard L3 engine:
– Max. output: 191kW (260PS) / 5,500rpm
– Max. torque: 380Nm / 3,000rpm
– Acceleration from 0...100 km/h: 6.6 seconds (under Mazda test conditions)
– Acceleration from 50...100 km/h (3rd gear): 5.9 seconds (under Mazda test
conditions)
– Acceleration from 60...80 km/h (4th gear): 3.0 seconds (under Mazda test conditions)
M6-MPS_00001
1 Power output 3 Engine speed

2 Torque
00-2 Service Training Mazda6 MPS Supplement

General Information
Scheduled Maintenance
Maintenance interval (number of momths or km (miles) which ever comes first)

Maintenance Months 12 24 36 48 60 72 84 96 108 120 132 144
interval X1000 km 5 15 30 45 60 75 90 105 120 135 150 165 180
X1000 miles 3.1 9.4 18.8 28.1 37.5 46.9 56.3 65.6 75.0 84.4 93.8 103.1 112.5
ENGINE
Engine valve clearance Audible inspect every 120,000km (75,000 miles), if noisy adjust
Engine oil*2 R R R R R R R R R R R R R
Engine oil filter *2 R R R R R R R R R R R R R
Drive belt *3 I I I
COOLING SYSTEM
Cooling system (including coolant level adjustment) I I I I I I
FL 22 type *4 Replace every 195,000 km (121,900 miles) or 11 years

Engine coolant
Others Replace at first 90,000Km (56,300 miles) or 4 years, after that every 2 years
FUEL SYSTEM
Air cleaner element*1 Replace every 60,000Km (37,500 miles) or 36 months
Fuel lines and hoses I I I I I I
IGNITION SYSTEM
Spark plugs Replace every 75,000 Km (46,900 miles)
EMISSION CONTROL SYSTEM
Evaporation system(if installed) I I I
ELECTRICAL SYSTEM
Battery electrolyte level and specific gravity I I I I I I I I I I I I
CHASSIS and BODY
Brakes lines hoses and connections I I I I I I I I I I I I
Brake fluid *6 R R R R R R
Parking brake I I I I I I I I I I I I
Power brake unit (Brake booster) I I I I I I I I I I I I
and hoses
Disc brakes I I I I I I I I I I I I
Power steering fluid, lines, hoses I I I I I I I I I I I I
and connections
Steering operation and linkages I I I I I I
Manual transaxle oil R R
Rear differential oil *6 *7
Transfer oil *7
Front and rear suspension and ball joints I I I I I I
Drive shaft dust boots I I I I I I
Exhaust system and heat shields I I
Body condtion
Inspect annualy
(for rust, corrosion and perforation)
Tires (including spare tire)
I I I I I I I I I I I I I
(with inflation pressure adjustment)
AIR CONDITIONER SYSTEM (if installed
Air filter (if installed) Replace every 40,000Km (25,000 miles) or 24 months
M6-MPS_00T002
I: Inspect: Inspect and clean, repair, adjust, or replace if necessary.
R: Replace
Service Training Mazda6 MPS Supplement 00-3

Mazda 6 Technical Training Mps Supplement
Full download: http://manualplace.com/download/mazda-6-technical-training-mps-supplement/
General Information
Remarks: Emission control and related systems
• The ignition and fuel systems are highly important to the emission control system and to
efficient engine operation. All inspections and adjustments must be made by an
Authorized Mazda Dealer.
• After the prescribed period, continue to follow the described maintenance at the
recommended intervals.
• Refer below for a description of items marked* in the maintenance chart.
*1: Also inspect and adjust the power steering and air conditioner drive belts, if installed.
*2: If the vehicle is operated under any of the following conditions, change the engine oil and
oil filter more often than recommended intervals:
– Driving in dusty conditions.
– Extended periods of idling or low speed operation.
– Driving for long period in cold temperatures or driving regularly at short distance only.
*3: Use FL22 type coolant in vehicles with the inscription “FL22” on the radiator cap itself or
the surrounding area. Use FL22 when replacing the coolant.
*4: If the vehicle is operated in very dusty or sandy areas, clean and if necessary, replace the
air cleaner element more often than the recommended intervals.
*5: If the brakes are used extensively (for example, continuous hard driving or mountain
driving) or if the vehicle is operated in extremely humid climates, change the brake fluid
annually.
*6: If the vehicle is operated under any of the following conditions, change the rear differential
oil every 45,000 km (28,100 miles):
– Towing a trailer or using a car-top carrier.
– Driving in dusty, sandy or wet condition.
– Extended periods of idling or low speed operation.
– Repeated short trips of less than 16 km (10 miles).
*7: If this component has been submerged in water, the oil should be changed.
*8: This is a full function check of electrical systems such as lights, wiper and washer
systems (including wiper blades), and power windows.
00-4 Service Training Mazda6 MPS Supplement
This is the cut pages sample. Download all 112 page(s) at: ManualPlace.com

Mazda 6 Technical Training Mps Supplement

Uploaded by

Copyright:

Available Formats

Mazda 6 Technical Training Mps Supplement

Uploaded by

Document Information

Original Description:

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Mazda 6 Technical Training Mps Supplement

Uploaded by

Copyright:

Available Formats

Mazda 6 Technical Training Mps Supplement

Full download: http://manualplace.com/download/mazda-6-technical-training-mps-supplement/

Mazda6 MPS Supplement

No liability can be accepted for any inaccuracies or omissions in this publication,

Service Training Mazda6 MPS Supplement

VIN (Vehicle Identification Number) Code.........................................................1

Table of Contents 00 Service Training Mazda6 MPS Supplement

VIN (Vehicle Identification Number) Code

Plant 0 = Hiroshima, 1 = Hofu

Engine Type L = 2.3L (L3 Turbo)

Body style 2 = 4SD

Vehicle type GG = Mazda6 MPS, Mazda6 (4SD, 5HB)

World manufacturer indication JMZ = Mazda (Europe)

Service Training Mazda6 MPS Supplement 00-1

Engine / Transaxle Combinations

1 Power output 3 Engine speed

00-2 Service Training Mazda6 MPS Supplement

Maintenance interval (number of momths or km (miles) which ever comes first)

Cooling system (including coolant level adjustment) I I I I I I

FL 22 type *4 Replace every 195,000 km (121,900 miles) or 11 years

Service Training Mazda6 MPS Supplement 00-3

Remarks: Emission control and related systems

00-4 Service Training Mazda6 MPS Supplement

You might also like