Index

2 Block Diagram.
3 Supply Board.
4 Channels In/Out Board Part 1/2.
5 Channels In/Out Board Part 2/2.
6 Main Board Part 1/7.
7 Main Board Part 2/7.
8 Main Board Part 3/7.
9 Main Board Part 4/7.
10 Main Board Part 5/7.
11 Main Board Part 6/7.
12 Main Board Part 7/7.
rd122 / rd122fx mixing consoles 13 Digital Effect CHEF High-Efx Board.
14 Rear In/Out Board.
15 Spare Part List.

SERVICE MANUAL
Notice
✔ Service must be carried out by qualified personnel only. Any tampering carried out by unqualified personnel during the guarantee period
will forfeit the right to guarantee.
✔ For a correct operation of the instrument, after having switched off, be careful to wait at least 3 seconds before switching on again.
✔ To improve the device's specifications, the schematic diagrams may be subject to change without prior notice.
All components marked by this symbol have special safety characteristics, when replacing any of these components use only
manufacturer's specified parts.
✔ The (µ) micro symbol of capacitance value is substituted by U.
✔ The (Ω) omega symbol of resistance value is substituted by E.
✔ The electrolytic capacitors are 25Vdc rated voltage unless otherwise specified.
✔ All resistors are 1/8W unless otherwise specified.
✔ All switches shown in the "OFF" position. All DC voltages measured to ground with a voltmeter 20KOhm/V.
✔ Soldering point. Supply voltage. Logic supply ground.
✔ Male connector. Test point. Analog supply ground.
✔ Female connector. Flag joined with one or more flags Chassis ground.
✔ M/F faston connector. with the same signal name inscribed. Earth ground.

ATTENTION Observe precautions when handling electrostatic sensitive devices.

code 270295 ✒ GENERALMUSIC S.p.A. Sales Division: 47842 S.Giovanni in Marignano (RN) ITALY - Via delle Rose, 12
☎ Phone +39(0)541/959511 - Fax +39(0)541/957404 - Internet: www.generalmusic.com
1
 1 2 3 4 5 6 7

RIGHT-BUS

SOLO(PFL)

EFX SEND
LEFT-BUS

ALT-4(R)
ALT-3(L)

LOGIC
AUX-1
AUX-2
AUX-3

AFL-R
AFL-L
AUX SENDS
MONO INPUT CHANNELS (1-8)
GAIN LO MID (FREQ) HI
AUX-1
AUX1
LEVEL
R
T
RD122/RD122FX
PHANTOM
POWER
+48V PAN
MAIN/ALT
LEFT-BUS
S
BLOCK DIAGRAM
FADER AUX SEND1
ALT-3 AUX2
2 + 80 100Hz-8kHz 12K LEVEL
MIC IN 3 3-BAND EQ RIGHT-BUS R
1
- +/-15db ALT-4
AUX-2 T
S 2TRACK OUTPUT
D D
AUX SEND2
LEFT
AUX3
LEVEL
LINE IN AFL-L R
AUX-3 T
S
RIGHT
AFL-R AUX SEND3
(DFX SEND)
MIC GAIN:0~60dB
LINE IN TRIM:+15dB~-45dB
LO CUT SOLO(PFL)
PRE AUX1
R 75Hz
1 2 MAIN MIX
LEVEL MAIN MIX OUTPUTS
RN HI PASS POST R
TN 1 2 T
T ( ON ) LEFT-BUS S

S AUX2 AUX-1 2
INSERT PRE 3
AUX-2 1
SG/OL POST
MAIN MIX LEFT

AUX3 R
T
LO L-M M-H HI RIGHT-BUS S
AUX-3

STEREO INPUT CHANNELS (9-12) 2

3
FADER BALANCE 1
R MAIN/ALT
RN - 80 500 3K 12K LEFT-BUS
MAIN MIX RIGHT
TN 4-BAND EQ
T ALT-3
+ +/-15db
S MAIN MIX INSERT
RIGHT-BUS ALT3-4 R
C LEFT(MONO) RN C
LEVEL
R ALT-4 TN
RN - 80 500 3K 12K T LEFT
TN 4-BAND EQ
ALT-3(L)
T S
+ +/-15db
S
R
RIGHT RN
AFL-L TN
ALT-4(R) T RIGHT
S
AFL-R ALT 3-4 TO MIX

LEFT-BUS ALT 3-4 OUTPUTS

SOLO(PFL) R
AUX1 T
S
SG/OL PRE RIGHT-BUS
1 2 ALT-3(L)
2TK TO MIX
POST ( ON )
1 2 R
AUX2 LEFT-BUS T
AUX-1 S
PRE
AUX-2 ALT-4(R)
POST RIGHT-BUS
STEREO AUX RETURN 1
3c R AUX3
2-TRACK INPUT
4d RN - ALT 3-4 2TK
2b TN LEFT
1a T + AUX-3
AUX1 RETURN MAIN MIX
5e S
LEFT(MONO) LEFT-BUS
3c R RIGHT
4d RN -
B 2b TN B
1a T + RIGHT-BUS
5e S
RIGHT CONTROL ROOM SOURCE
AUX2 RETURN SOLO ACTIVE
STEREO AUX RETURN 2 SOLO CTRL
3c R LEFT-BUS
4d RN -
2b TN
1a T AFL L
+
5e S RIGHT-BUS
LEFT(MONO) LEFT METER
3c R
4d RN -
2b TN AFL R
1a T +
AUX3 / DFX
5e S RETURN
RIGHT SOLO MODE
LEFT-BUS PFL LED RIGHT METER
( AFL )
STEREO AUX RETURN 3 (DFX RETURN) SOLO(PFL) (LEVEL SET)
( PFL )
3c R
4d RN -
2b TN RIGHT-BUS
1a T +
5e S PHONES OUTPUT
LEFT R
T PHONES
3c R AUX3 / DFX S
4d RN - TO AUX1
2b TN
1a T + AUX-1
5e S
A RIGHT CONTROL ROOM OUTPUT A
R
DSP BOARD AUX-1 T LEFT
S
PRESETS

VARIATIONS R
T RIGHT
MUTE CONTROL ROOM S
& PHONES
RIGHT-BUS

SOLO(PFL)

EFX SEND
LEFT-BUS

DRW G.BOCCATO DWG# 550775 PCB# GENERALMUSIC S.p.A. ITALY

ALT-4(R)
ALT-3(L)

DSP FOOTSWITCH
LOGIC

BLOCK DIAGRAM
AUX-1
AUX-2
AUX-3

AFL-R

ALL RIGHTS ARE RESERVED, NO COPIES

AFL-L

CKD G.RICCI DATE: 21/06/2004

OR REPRODUCE THIS DOCUMENT WITHOUT
APP. N.ZAVATTA REV: A WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8

2
 1 2 3 4

AC INPUT
MAINS
SKK235012 - TRANSFORMER 230VAC (EU)
230Vac 50Hz ±10% (EU)
SWITCH SKK235013 - TRANSFORMER 115VAC (US)
115Vac 50-60Hz ±10% (US)
3
2
FUSE T250mA 250V 1
D D

SKK768190 - RD122FX SUPPLY BOARD ASSEMBLY

D3 FX VERSION ONLY
SKK768191 - RD122 SUPPLY BOARD ASSEMBLY 1N4002
TP3
+17V
+17V +5 VD
D1 D2 TR1 TR4
1N4002 1N4002 7815A 1 3 7805 1 3
TP1
18VAC
2 2 C10
CN1 C1 D5 C3 1000uF/16V
3P-3.9 2200uF/25V 1N4002 47uF/25V
C D4 C
3 1N4002 PGND PGND
2
1 PGND
CN3
PGND D8 2.5-8P
1N4002 C4
TP2 47uF/25V 1
PGND C2

TO MAIN BOARD CN1

18VAC D10 +5 VD 2
2200uF/25V +17V 3
D6 D7 1 1N4002
1N4002 1N4002 2 3 4
-17V -17V 5
TR2 6
7
7915A D9 +48V 8
1N4002 TP4
-17V PHANTOM
POWER
PGND

B D11 D12 B
1N4002 1N4002
CN2 PHANTOM TP5
2P-2.5 +48V
TR3

1
2
D14 C7 TIP122 R3
1N4002 220uF/100V 10R
+48V

C6
100uF/100V R1 R2 R4
390K 10K C9 20K
47uF/100V

ZD1
C5 D13 C8 1N5261
100uF/100V 1N4002 47uF/100V (47V 0.5W)

A A

PGND

DRW G.BOCCATO DWG# 550776 PCB# RD122PWR GENERALMUSIC S.p.A. ITALY

CKD G.RICCI DATE: 21/06/2004 ALL RIGHTS ARE RESERVED, NO COPIES

APP. N.ZAVATTA REV: A

SUPPLY BOARD OR REPRODUCE THIS DOCUMENT WITHOUT
WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4

3
 1 2 3 4 5 6 7 8 9 10 11 12

SKK768194 - RD122/RD122FX CHANNELS IN/OUT BOARD ASSEMBLY (part 1 of 2)

PH PWR +VCC +VCC +VCC R19 +VCC PH PWR +VCC +VCC +VCC R237 +VCC
2K49 2K49
R1 R2 R11 C5 R20 D1 R21 U2A R73 R76 R234 C174 R236 D5 R238 U17A
C1 C49 C173 C195
6K81 6K81 10N 2K49 10N 2K49 C44 BAS316 2K49 4580M C99 6K81 6K81 10N 2K49 10N 2K49 C189 BAS316 2K49 4580M C221
22P 22P
1000u/10V 3 47u/25V 1000u/10V 3 47u/25V
R46 C11 1 R9 C114 1
4R7 47u/63V TR1 TR5 U1A R123 4R7 47u/63V TR29 TR31 U16A R271
1 TR6 2 1 TR30 2
BC857 BC857 4580M 5K11 BC857 BC857 4580M 5K11
D
MIC 1 3
2
C21
BC857
3
C50
R65
LO CUT MIC 5 3
2
C69
BC857
3
C196
R222
LO CUT D
4 1 20K 4 1 20K
330P 2 22P SW1A 330P 2 22P SW9A
X1 R61 R143 PS-22E85L X28 R221 R285 PS-22E85L
20K 10K0 R124 20K 10K0 R272
JY-5042-030G R47 R83 R87 5K11 JY-5042-030G R10 R261 R262 5K11
4R7 C12 C51 R125 4R7 C113 C193 R270
47u/63V 470R 470R C93 47u/63V 470R 470R C211
3c R 22P 5K11 SW1B 3c R 22P 5K11 SW9B
VR1 0.22u/50V PS-22E85L VR5 0.22u/50V PS-22E85L
4d RN C26 R93 -VCC O10K 4d RN C10 R142 -VCC O10K
U1B U16B
LINE IN1 2b
1a
TN
T
22u/35V 6K34
TR20
5 4580M C85
0.22u/50V
R199
4K99
INS-CH1
LINE IN5 2b
1a
TN
T
22u/35V 6K34
TR14
5 4580M C210
0.22u/50V
R301
4K99
INS-CH5

7 7
5e S R94 TR16 A1316 R54 6 R153 5e S R141 TR13 A1316 R39 6 R297
C27 4R7 R144 1K3 C9 4R7 R286 1K3
22u/35V 6K34 A1316 C100 22u/35V 6K34 A1316 C222
X2 10K0 X29 10K0
JY-6351G-02-250 C34 6 47u/25V JY-6351G-02-250 C181 6 47u/25V
1N R22 7 1N R239 7
R101 2K49 C52 C86 5 R213 2K49 C194 C209 5
1K50 R102 22P 0.22u/50V 1K50 R214 22P 0.22u/50V
R12 1K50 R233 1K50
MIC GAIN=0~-60dB R126 R66 MIC GAIN=-10~-60dB R269 R223
2K49 C38 R23 -VCC 5K11 R157
U2B
20K 2K49 C182 R235 -VCC 5K11 R293
U17B
20K
LINE IN GAIN=-15~-40dB 1N 2K49 4580M LINE IN GAIN=+10~-40dB 1N 2K49 4580M
62K 62K
-VCC -VCC -VCC -VCC
PH PWR +VCC +VCC +VCC R24 +VCC PH PWR +VCC +VCC +VCC R247 +VCC
2K49 2K49
R3 R4 R13 C6 R25 D2 R26 U4A R91 R109 R241 C177 R244 D6 R249 U19A
C2 C53 C175 C199
6K81 6K81 10N 2K49 10N 2K49 C45 BAS316 2K49 4580M C101 6K81 6K81 10N 2K49 10N 2K49 C190 BAS316 2K49 4580M C223
22P 22P
1000u/10V 3 47u/25V 1000u/10V 3 47u/25V
R48 C13 1 R40 C168 1
4R7 47u/63V TR2 TR7 U3A R127 4R7 47u/63V TR32 TR34 U18A R275
1 TR8 2 1 TR33 2
BC857 BC857 4580M 5K11 BC857 BC8574580M 5K11
MIC 2 3
2
C22
BC857 3
C54
R67
20K LO CUT
MIC 6 3
2
C70
BC857 3
C201
R225
20K LO CUT
4 1 4 1
330P 2 22P SW2A 330P 2 22P SW10A
X3 R62 R145 PS-22E85L X30 R224 R288 PS-22E85L
20K 10K0 R128 20K 10K0 R276
JY-5042-030G R49 R84 R88 5K11 JY-5042-030G R42 R263 R264 5K11
4R7 C14 C55 R129 4R7 C115 C197 R274
47u/63V 470R 470R C94 47u/63V 470R 470R C214
3c R 22P 5K11 SW2B 3c R 22P 5K11 SW10B
VR2 0.22u/50V PS-22E85L VR6 0.22u/50V PS-22E85L
4d RN C28 R95 -VCC O10K 4d RN C20 R152 -VCC O10K
U3B U18B
C LINE IN2 2b
1a
TN
T
22u/35V 6K34
TR21
5 4580M C87
0.22u/50V
R200
4K99
INS-CH2
LINE IN6 2b
1a
TN
T
22u/35V 6K34
TR24
5 4580M C213
0.22u/50V
R302
4K99
INS-CH6
C
7 7
R96 TR17 A1316 R55 R154 R151 TR15 A1316 R43 R298
5e S C29 6 1K3 5e S C19 6 1K3
6K34 A1316 4R7 R146 6K34 A1316 4R7 R287
22u/35V 10K0 C102 22u/35V 10K0 C225
X4 X31
JY-6351G-02-250 C35 6 47u/25V JY-6351G-02-250 C183 6 47u/25V
1N C88 1N C212 7
R27 C56 0.22u/50V 7 R248 C198 0.22u/50V
R103 5 R215 5
1K50 R104 2K49 22P 1K50 R216 2K49 22P
R14 1K50 R240 1K50
R130 R158 R68 R273 R294 R226
2K49 C39 R28 -VCC 5K11 62K
U4B
20K 2K49 C184 R243 -VCC 5K11 62K
U19B
20K
1N 2K49 4580M 1N 2K49 4580M

-VCC -VCC -VCC -VCC

PH PWR +VCC +VCC +VCC R29 +VCC PH PWR +VCC +VCC +VCC R246 +VCC
2K49 2K49
R5 R6 R15 C7 R30 D3 R31 U6A R92 R110 R242 C178 R245 D7 R250 U21A
C3 C57 C176 C200
6K81 6K81 10N 2K49 10N 2K49 C46 BAS316 2K49 4580M C103 6K81 6K81 10N 2K49 10N 2K49 C191 BAS316 2K49 4580M C224
22P 22P
1000u/10V 3 47u/25V 1000u/10V 3 47u/25V
R50 C15 1 R41 C169 1
4R7 47u/63V TR3 TR9 U5A R131 4R7 47u/63V TR35 TR39 U20A R280
1 TR10 2 1 TR37 2
BC857 BC857 4580M 5K11 BC857 BC8574580M 5K11
MIC 3 3
2
C23
BC857 3
C58
R69
LO CUT
MIC 7 3
2
C75
BC857 3
C206
R230
LO CUT
4 1 20K 4 1 20K
330P 2 22P SW3A 330P 2 22P SW11A
X5 R63 R147 PS-22E85L X32 R227 R290 PS-22E85L
20K 10K0 R132 20K 10K0 R282
JY-5042-030G R51 R85 R89 5K11 JY-5042-030G R45 R265 R267 5K11
4R7 C16 C59 R133 4R7 C170 C202 R279
47u/63V 470R 470R C95 47u/63V 470R 470R C217
3c R 22P 5K11 SW3B 3c R 22P 5K11 SW11B
VR3 0.22u/50V PS-22E85L VR7 0.22u/50V PS-22E85L
4d RN C30 R97 -VCC O10K 4d RN C42 R175 -VCC O10K
U5B U20B
LINE IN3 2b
1a
TN
T
22u/35V 6K34 5 4580M C89
0.22u/50V
R201 INS-CH3
LINE IN7 2b
1a
TN
T
22u/35V 6K34 5 4580M C216
0.22u/50V
R303 INS-CH7
TR22 7 4K99 TR26 7 4K99
5e S R98 TR18 A1316 R56 6
R155 5e S R172 TR25 A1316 R59 6
R299
C31 4R7 R148 1K3 C25 4R7 R291 1K3
22u/35V 6K34 A1316 C104 22u/35V 6K34 A1316 C227
X6 10K0 X33 10K0
JY-6351G-02-250 C36 6 47u/25V JY-6351G-02-250 C185 6 47u/25V
1N R32 C90 7 1N R256 C215 7
R105 C60 5 R217 C204 5
1K50 R106 2K49 0.22u/50V 1K50 R218 2K49 0.22u/50V
B
22P 22P B
R16 1K50 R251 1K50
R134 R159 U6B R70 R277 R295 U21B R231
2K49 C40 R33 -VCC 5K11 62K 20K 2K49 C186 R253 -VCC 5K11 62K 20K
1N 2K49 4580M 1N 2K49 4580M
-VCC -VCC -VCC -VCC
PH PWR +VCC +VCC +VCC R34 +VCC PH PWR +VCC +VCC +VCC R255 +VCC
2K49 2K49
R7 R8 R17 C8 R35 D4 R36 U8A R139 R140 R252 C180 R254 D8 R257 U23A
C4 C61 C179 C205
6K81 6K81 10N 2K49 10N 2K49 C47 BAS316 2K49 4580M C105 6K81 6K81 10N 2K49 10N 2K49 C192 BAS316 2K49 4580M C226
22P 22P
1000u/10V 3 47u/25V 1000u/10V 3 47u/25V
R52 C17 1 R44 C172 1
4R7 47u/63V TR4 TR11 U7A R135 4R7 47u/63V TR36 TR40 U22A R281
1 TR12 2 1 TR38 2
BC857 BC857 4580M 5K11 BC857 BC857 4580M 5K11
MIC 4 3
2
C24
BC857 3
C62
R71
LO CUT
MIC 8 3
2
C76
BC857 3
C207
R229
LO CUT
4 1 20K 4 1 20K
330P 2 22P SW4A 330P 2 22P SW12A
X7 R64 R149 PS-22E85L X34 R228 R289 PS-22E85L
20K 10K0 R136 20K 10K0 R283
JY-5042-030G R53 R86 R90 5K11 JY-5042-030G R58 R266 R268 5K11
C18 C63 R137 C171 C203 R278
R 4R7 47u/63V 470R 470R C96 R 4R7 47u/63V 470R 470R C220
3c 22P 5K11 SW4B 3c 22P 5K11 SW12B
VR4 0.22u/50V PS-22E85L VR8 0.22u/50V PS-22E85L
4d RN C32 R99 -VCC O10K 4d RN C48 R182 -VCC O10K
U7B U22B
LINE IN4 2b TN
1a T
22u/35V 6K34
TR23
5 4580M C91
0.22u/50V
R202
4K99
INS-CH4
LINE IN8 2b TN
1a T
22u/35V 6K34
TR28
5 4580M C219
0.22u/50V
R304
4K99
INS-CH8

7 R156 7 R300
5e S R100 TR19 A1316 R57 6 5e S R181 TR27 A1316 R60 6
C33 4R7 R150 1K3 C43 4R7 R292 1K3
22u/35V 6K34 A1316 C106 22u/35V 6K34 A1316 C228
X8 10K0 X35 10K0
JY-6351G-02-250 C37 6 47u/25V JY-6351G-02-250 C187 6 47u/25V
1N C92 7 1N C218 7
R107 R37 0.22u/50V R219 R260 0.22u/50V
2K49 C64 5 2K49 C208 5
1K50 R108 22P 1K50 R220 22P
R18 1K50 R258 1K50
R138 R160 U8B R72 R284 R296 U23B R232
2K49 C41 R38 -VCC 5K11 62K 20K 2K49 C188 R259 -VCC 5K11 62K 20K
1N 2K49 4580M 1N 2K49 4580M
-VCC -VCC -VCC -VCC

C120 C121 C124 C125 C126 C127 C128 C129 C229 C231 C233 C235 C237 C239 C241 C243
A 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N A
+VCC +VCC
8 8 8 8 8 8 8 8 8 8 8 8 8 8 8 8
U1C U2C U3C U4C U5C U6C U7C U8C U16C U17C U18C U19C U20C U21C U22C U23C
4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M
4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4
-VCC -VCC
C122 C123 C132 C133 C134 C135 C136 C137 C230 C232 C234 C236 C238 C240 C242 C244
100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N

DRW G.BOCCATO DWG# 550777 PCB# RD122PU2 GENERALMUSIC S.p.A. ITALY

CKD G.RICCI DATE: 22/06/2004 CHANNELS IN/OUT BOARD ALL RIGHTS ARE RESERVED, NO COPIES
OR REPRODUCE THIS DOCUMENT WITHOUT
APP. N.ZAVATTA REV: A (part 1 of 2) WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8 9 10 11 12

4
 1 2 3 4 5 6 7 8

SKK768194 - RD122/RD122FX CHANNELS IN/OUT BOARD ASSEMBLY (part 2 of 2)

C71
R163
10K0 22P STEREO AUX 3c
3c 4d
4d
R
RN RETURN1 2b
LINE IN 9 2b
1a
TN
T
C152
100P R205 LEFT 1
1a AUX-RTN1-L
C97
LEFT(MONO) 1K5
R171 C109
(MONO / MASTER) 5e 22P
5e S 2 10K0 47u/25V R119
R164 R161 120R
10K0 1 PRE-CH9 X19
D X10 3 JY-6351G-02-250 10K0 D
JY-6351G-02-250 U11A 6
4580M R77 2 7
C153
100P C65
22P
R173
10K0
20K 3c CTRL-R-R 3
1 5
R120 PHONES
4d 120R 3c
2b U24A U24B 4d
RIGHT 1 1a AUX-RTN1-R BA15218N BA15218N 2b
SW5A 1a
5e C98
PS-22E85L (LEVEL +4dBu/-10dBv) 22P R121 5e
C72 X20 R162 120R
R165 JY-6351G-02-250 X18
10K0 22P 10K0
3c R 6 JY-6351G-02-250
4d RN STEREO AUX 2 7
LINE IN 10 2b
1a
TN
T
C154
100P R206 RETURN2
3c
4d CTRL-R-L 3
1 5
R122
RIGHT 1K5
R174 C110 2b 120R
5e S 6 10K0 47u/25V LEFT 2 1a AUX-RTN2-L U25A U25B
R166 BA15218N BA15218N
10K0 7 PRE-CH10
X11 5 5e
JY-6351G-02-250
U11B X21 R111
C155 C66 R176 4580M R78
20K JY-6351G-02-250 120R
100P 22P 10K0 R 3c
RN 4d
TN 2b
C
3c
4d
AUX-SEND1 T 1a AUX SEND1 C
SW5B
PS-22E85L (LEVEL +4dBu/-10dBv) 2b R112 S 5e
RIGHT 2 1a AUX-RTN2-R 120R
X23
R183 C77 5e JY-6351G-02-250
10K0 22P
3c R X22 R113
4d RN JY-6351G-02-250 120R
LINE IN 11 2b
1a
TN
T
C160
100P R209
R 3c
RN 4d
LEFT(MONO) R184 C116 TN 2b
5e S R185
1K5 2 10K0
1
47u/25V
PRE-CH11
STEREO AUX 3c
AUX-SEND2 T 1a AUX SEND2
X12 10K0
3 RETURN3 4d
2b EFXRTN-L
R114
120R
S 5e
JY-6351G-02-250 U13A
4580M R79 LEFT 2 1a AUX-RTN3-L X24
C161 C78 R186 JY-6351G-02-250
20K 5e
100P 22P 10K0
R74
X25 120R
JY-6351G-02-250 R 3c
SW6A RN 4d
PS-22E85L (LEVEL +4dBu/-10dBv) TN 2b
C79 3c
AUX-SEND3 T 1a AUX SEND3
R187 R75
10K0 22P 4d S 5e
3c R 2b EFXRTN-R 120R
4d RN RIGHT 2 1a AUX-RTN3-R X9
B B
LINE IN 12 2b
1a
TN
T
C162
100P R210 5e
JY-6351G-02-250
RIGHT 1K5
R188 C117 R347
5e S 6 10K0 47u/25V X26 C107 C140
R189 47R 47u/25V 100N
10K0 7 PRE-CH12 JY-6351G-02-250
X13 5 +VCC
8 8
JY-6351G-02-250 U13B C142 C144 U24C U25C
4580M R80 100N 100N
C163 C80 R190
20K +VCC 2-TRACK IN 2-TRACK OUT R346 BA15218N BA15218N

100P 22P 10K0 8 8 47R 4 4

U11C U13C X27 -VCC
4580M 4580M SCP6873NS3232 C108 C141
SW6B 4 4 47u/25V 100N
PS-22E85L (LEVEL +4dBu/-10dBv) 1 4 MAIN-L-2
-VCC L(WHITE)
C147 C149 R203
100N 100N 1K
CN1 CN6 CN3 CN7 CN4
9P-2.0 9P-2.0 12P-B24A 12P-B24A 12P-2.0
TO REAR IN/OUT BOARD CN1

TO REAR IN/OUT BOARD CN3

2 5 MAIN-R-2
RTN-CH1 RTN-CH5 RTN-CH1 PRE-CH9 EFXRTN-L R(RED)
1 1 1 1 1
INS-CH1 2 INS-CH5 2 RTN-CH2 2 PRE-CH10 2 EFXRTN-R 2 R204
TO MAIN BOARD CN2

TO MAIN BOARD CN3

TO MAIN BOARD CN4

RTN-CH2 3 RTN-CH6 3 RTN-CH3 3 PRE-CH11 3 3 1K

6
INS-CH2 4 INS-CH6 4 RTN-CH4 4 PRE-CH12 4 AUX-SEND1 4
RTN-CH3 RTN-CH7 RTN-CH5 AUX-SEND2 2TK-IN-L
INS-CH3 5 INS-CH7 5 RTN-CH6 5 AUX-RTN1-L 5 AUX-SEND3 5
RTN-CH4 6 RTN-CH8 6 RTN-CH7 6 AUX-RTN1-R 6 CTRL-R-L 6 2TK-IN-R
A 7 7 7 7 7 A
INS-CH4 INS-CH8 RTN-CH8 AUX-RTN2-L CTRL-R-R
8 8 8 AUX-RTN2-R 8 2TK-IN-L 8
9 9 PH PWR +VCC 9 AUX-RTN3-L 9 2TK-IN-R 9
10 AUX-RTN3-R 10 MAIN-L-2 10
-VCC 11 11 MAIN-R-2 11
12 12 12

DRW G.BOCCATO DWG# 550778 PCB# RD122PU2 GENERALMUSIC S.p.A. ITALY

CKD G.RICCI DATE: 22/06/2004 CHANNELS IN/OUT BOARD ALL RIGHTS ARE RESERVED, NO COPIES
OR REPRODUCE THIS DOCUMENT WITHOUT
APP. N.ZAVATTA REV: A (part 2 of 2) WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8

5
 1 2 3 4 5 6 7 8

EQ HI (12K) SW2:MUTE/ALT3-4
C20 C152 C169 C154 R309 VR6A SW3:SOLO,PFL
VR2 VR1
47u/25V B50K MID (FREQ=100Hz-8K) 6.8n(M) B50K 6.8n(M) C97 22P 1K JQ10K PAN SW2A
R185
RTN-CH1
RTN-CH1
C96
22P
R391 R184 R250
3K3
PS-42E85L 1
2
LEFT-BUS SKK768195 - RD122FX MAIN BOARD ASSEMBLY (part 1 of 7)
22P 12K C4 R310 3
R36 R37
10K
R18
1M
C3
5K1
2
1
47u/25V 1K
VR6B
JQ10K
R187 SW2B
ALT-3
SKK768196 - RD122 MAIN BOARD ASSEMBLY (part 1 of 6)
10K 6 3K9 3 PS-42E85L 4
C1 47u/25V 3K3 RIGHT-BUS
6.8n(M) 7 6 GND U1A 5
5 7 4580M 6
ALT-4
D 5 R508 D
R78 VR7A
U36B 10KD 15K GND R268 SW3A
5K1 R38 PS-42E85L 1
4580M U1B LEVEL 20K GND
VR97A R17 3 10K GND 4580M 2
500KC 3K 1 3
AFL-L
2 GND
U36A GND R269 SW3B
GND C88 4580M PS-42E85L 4
152(M) C128 C129 20K GND
5
R1 33n(M) 33n(M) 6
6K2 AFL-R C197 C285
+VCC
SW2C 100N 100N
PS-42E85L 7 SOLO(PFL) AUX-3 +VCC 8 8
R2 R371 VR3 R372 8
VR97B 6K2 5K6 B50K 5K6 C144 R176 U1C U36C
500KC R27 9
4580M
LO (80Hz) 2.2u/50V 6K8 1K5 GND VR44 4580M
SW1A R215 W50K 4 4
SW3C PS-22E85L 1 J1 5K6
LD2 R92 PS-42E85L 7 -VCC
10K 2 POST
YEL 8
GND
3 GND C198 C286
(SOLO) R154 LD3 9 SW1B AUX-1 100N 100N
-VCC 4K7 RED PS-22E85L 4 GND
(PRE)
10 R82
R144 TR2 PEAK 5
11 2K2 6 VR4
GND 33K BC847 R188
12 LOGIC
LOGIC
W50K C199 C287
D2 AUX2 PRE/POST 5K6
SW3D TR1 AUX-2 100N 100N
BAS316 (LOGIC=2.0V or 0.5V) BC847 R189 +VCC
PS-42E85L GND 8 8
5K6
VR5 U2C U37C
W50K 4580M 4580M
PGND
4 4
-VCC
GND
C200 C288
100N 100N
GND

EQ HI (12K) SW5:MUTE/ALT3-4
C29 C156 C171 C155 R403 VR13A SW6:SOLO,PFL
C VR9 VR8 C
47u/25V B50K MID (FREQ=100Hz-8K) 6.8n(M) B50K 6.8n(M) C102 22P 1K JQ10K PAN SW5A
C201 C289
22P R186 PS-42E85L 1 100N 100N
RTN-CH2 3K3
RTN-CH2 LEFT-BUS +VCC
C100 R393 R196 R255 2 8 8
22P 5K1 12K C16 R405 VR13B 3
ALT-3 U3C U38C
1M 2 47u/25V
R44 R47 R22 1K JQ10K SW5B 4580M 4580M
10K C14 1 R199
10K 6 3K9 3 PS-42E85L 4 4 4
C5 47u/25V 3K3 RIGHT-BUS
6.8n(M) 7 6 GND U2A 5
-VCC
5 7 4580M 6
ALT-4 C202 C290
5 R509
R101 VR14A 15K GND SW6A 100N 100N
5K1 U37B R49 10KD R272 PS-42E85L 1 GND
4580M U2B 20K GND
VR98A R21 3 10K GND 4580M LEVEL 2
500KC 3K 1 3
AFL-L
2 GND
U37A GND R273 SW6B
GND C90 4580M PS-42E85L 4
152(M) C132 C133 20K GND
5
R5 33n(M) 33n(M) 6
6K2 +VCC
AFL-R
SW5C
PS-42E85L 7 SOLO(PFL) AUX-3
R6 R379 VR10 R380 8
VR98B 6K2 5K6 B50K 5K6 C146 R178
500KC R35 9
GND
LO (80Hz) 2.2u/50V 6K8 1K5
R217
VR46
LD5 SW4A J2 5K6 W50K
SW6C
R100 PS-42E85L PS-22E85L 1
YEL 7 2 POST
(SOLO) 10K GND
8 3 GND
-VCC R156 LD6 9 SW4B AUX-1
10 R84 4K7 RED PS-22E85L 4 (PRE)
GND
11 2K2
R146 TR6 PEAK 5
12 LOGIC 33K 6 VR11
LOGIC BC847 R201 W50K
D4 AUX2 PRE/POST
SW6D BAS316 (LOGIC=2.0V or 0.5V) 5K6
TR5 AUX-2
PS-42E85L BC847 R202 GND
5K6
VR12
B W50K B
PGND

GND

EQ HI (12K) R404
SW8:MUTE/ALT3-4
C30 C157 VR15 C174 C161 VR20A SW9:SOLO,PFL
VR16
47u/25V B50K MID (FREQ=100Hz-8K) 6.8n(M) B50K 6.8n(M) C103 22P 1K JQ10K PAN SW8A
22P R198 PS-42E85L 1
RTN-CH3 3K3
RTN-CH3 LEFT-BUS
C101 R394 R197 R256 2
22P 5K1 12K C17 R406 VR20B 3
ALT-3
1M 2 47u/25V
R46 R48 R23 1K JQ10K SW8B
10K C15 1 R200
10K 6 3K9 3 PS-42E85L 4
C11 47u/25V 3K3 RIGHT-BUS
6.8n(M) 7 6 GND U3A 5
5 7 4580M 6
ALT-4
5 R510
R165 VR21A 15K GND SW9A
5K1 U38B R61 10KD R276 PS-42E85L 1
4580M U3B 20K GND
VR99A R28 3 10K GND 4580M LEVEL 2
500KC 3K 1 3
AFL-L
2 GND
U38A GND R277 SW9B
GND C92 4580M PS-42E85L 4
152(M) C136 C137 20K GND
5
R9 33n(M) 33n(M) 6
6K2 +VCC
AFL-R
SW8C
PS-42E85L 7 SOLO(PFL) AUX-3
R10 R383 VR17 R384 8
VR99B 6K2 5K6 B50K 5K6 C148 R180
500KC R45 9
GND
LO (80Hz) 2.2u/50V 6K8 1K5 VR48
SW7A R219 W50K
SW9C PS-22E85L 1 J3 5K6
LD8 R110 PS-42E85L
10K 7 2 POST
YEL 8
GND
3 GND
(SOLO) R158 LD9 9 SW7B AUX-1
A -VCC 4K7 RED PS-22E85L 4 A
(PRE)
10 R86
R148 TR10 PEAK 5
11 2K2 6 VR18
GND 33K BC847 R212
12 LOGIC
LOGIC
W50K
D6 AUX2 PRE/POST 5K6
TR9 AUX-2
SW9D BAS316 (LOGIC=2.0V or 0.5V) BC847 R213
PS-42E85L GND
5K6
VR19
W50K
PGND

DRW G.BOCCATO DWG# 550780 PCB# RD122MN1 GENERALMUSIC S.p.A. ITALY

GND
CKD G.RICCI DATE: 22/06/2004 ALL RIGHTS ARE RESERVED, NO COPIES

APP. N.ZAVATTA REV: A

MAIN BOARD (part 1 of 7) OR REPRODUCE THIS DOCUMENT WITHOUT
WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8

6
 1 2 3 4 5 6 7 8

EQ HI (12K) SW11:MUTE/ALT3-4
C76
47u/25V
VR23
B50K MID (FREQ=100Hz-8K)
C163
6.8n(M)
VR22
B50K
C275
6.8n(M) C109
C168
22P
R421
1K
VR27A
JQ10K PAN
SW12:SOLO,PFL
SW11A
SKK768195 - RD122FX MAIN BOARD ASSEMBLY (part 2 of 7)
22P R210 PS-42E85L 1
RTN-CH4
RTN-CH4 1 3 3K3 LEFT-BUS SKK768196 - RD122 MAIN BOARD ASSEMBLY (part 2 of 6)

2
C108 R397 R209 R259 2
22P 5K1 12K C28 R422 VR27B 3
ALT-3
1M 2 47u/25V
R59 R60 R30 1K JQ10K SW11B
10K C27 1 R211
10K 6 3K9 3 6 4 PS-42E85L 4
C12 47u/25V 3K3 RIGHT-BUS

5
6.8n(M) 7 6 GND U4A 5
5 7 4580M 6
ALT-4
D 5 R517 D
R166 VR28A
U39B 10KD 15K GND R278 SW12A
5K1 R62 PS-42E85L 1
4580M U4B LEVEL 20K GND
VR100A R29 3 10K GND 4580M 2
500KC 3K 1 3
AFL-L
2 GND
U39A GND R279 SW12B
GND C93 4580M PS-42E85L 4
152(M) C140 C141 20K GND
5
R13 33n(M) 33n(M) 6
6K2 +VCC
AFL-R
C293 C295
SW11C
PS-42E85L 7 SOLO(PFL) AUX-3 100N 100N
R14 R387 VR24 R388 8
+VCC
8 8
VR100B 6K2 5K6 B50K 5K6 C150 R182
500KC R51 9
GND U40C U41C
LO (80Hz) 2.2u/50V 6K8 1K5
R223
VR50
4580M
SW10A W50K 4580M
SW12C PS-22E85L 1 J4 5K6
R111 PS-42E85L 4 4
LD11 7 2 POST
YEL 10K GND -VCC
8 3 GND
(SOLO) R160 LD12 9 SW10B AUX-1 C294 C296
-VCC 4K7 RED PS-22E85L 4 100N 100N
(PRE)
10 R89
R150 TR16 PEAK 5 R221 GND
11 2K2 6 VR25
GND 33K BC847 5K6
12 LOGIC
LOGIC
W50K
D8 AUX2 PRE/POST
TR15 AUX-2
SW12D BAS316 (LOGIC=2.0V or 0.5V) BC847 C297 C299
PS-42E85L R222
GND
100N 100N
VR26 +VCC
5K6 W50K 8 8
PGND
U42C U43C
4580M 4580M
GND 4 4
-VCC
EQ HI (12K) SW33:MUTE/ALT3-4 C298 C300
C24 C153 C170 C281 R346 VR71A SW34:SOLO,PFL 100N 100N
VR66 VR65
47u/25V B50K MID (FREQ=100Hz-8K) 6.8n(M) B50K 6.8n(M) C99 22P 1K JQ10K PAN SW33A GND
22P R81 PS-42E85L 1
C RTN-CH5 1 3 3K3 C
RTN-CH5 LEFT-BUS

2
C98 R392 R80 R455 2
22P 5K1 12K C26 R347 VR71B 3
ALT-3
1M 2 47u/25V
R39 R41 R20 1K JQ10K C203 C291
10K C25 1 R91 SW33B
10K 6 3K9 3 6 4 PS-42E85L 4 100N 100N
C2 47u/25V 3K3 RIGHT-BUS +VCC

5
6.8n(M) 7 6 GND U41A 5 8 8
5 7 4580M 6
ALT-4 U4C U39C
5 VR72A R518
R79 15K GND SW34A 4580M 4580M
5K1 U40B R42 10KD R459 PS-42E85L 1
U41B 20K 4 4
VR68A R19 3
4580M 10K GND LEVEL 2
GND
3K 4580M -VCC
500KC 1 3
2 GND
AFL-L C204 C292
U40A GND SW34B 100N 100N
C89 R460 PS-42E85L 4 GND
GND 4580M 20K
152(M) C130 C131 5
GND
R3 33n(M) 33n(M) 6
6K2 +VCC
AFL-R
SW33C AUX-3
PS-42E85L 7 SOLO(PFL)
R4 R377 VR67 R378 8
VR68B 6K2 5K6 B50K 5K6 C277 R451 VR45
500KC R431 9
GND R216
LO (80Hz) 2.2u/50V 6K8 1K5 SW32A J9 5K6 W50K
PS-22E85L 1
R43 SW34C 2 POST
LD55 PS-42E85L 7 3 GND
YEL 10K GND AUX-1
LD56 8 SW32B
(SOLO) R427 9 PS-22E85L 4 (PRE)
-VCC 4K7 RED 5 R93
10 R367
R415 TR26 PEAK 6 5K6 VR69
11 2K2 W50K
GND 33K BC847 AUX2 PRE/POST
12 LOGIC
LOGIC AUX-2
D10 TR25
SW34D BAS316 (LOGIC=2.0V or 0.5V) BC847 R99
GND
PS-42E85L VR70
5K6 W50K
PGND
B B
GND

EQ HI (12K) SW36:MUTE/ALT3-4
C32 C160 C273 C282 R411 VR79A SW37:SOLO,PFL
VR74 VR73
47u/25V B50K MID (FREQ=100Hz-8K) 6.8n(M) B50K 6.8n(M) C106 22P 1K JQ10K PAN SW36A
22P R112 PS-42E85L 1
RTN-CH6 1 3 3K3
RTN-CH6 2 LEFT-BUS
C104 R395 R103 R456 2
22P 5K1 12K C74 R413 VR79B 3
ALT-3
1M 2 47u/25V
R52 R54 R25 1K JQ10K SW36B
10K C72 1 R119
10K 6 3K9 3 6 4 PS-42E85L 4
C7 47u/25V 3K3 RIGHT-BUS

5
6.8n(M) 7 6 GND U43A 5
5 7 4580M 6
ALT-4
5 VR80A R521
R102 15K GND SW37A
5K1 U42B R57 10KD R461 PS-42E85L 1
U43B 20K
VR75A R24 3
4580M 10K GND LEVEL 2
GND
3K 4580M
500KC 1 3
AFL-L
2 GND
U42A GND R462 SW37B
GND C91 4580M PS-42E85L 4
152(M) C134 C135 20K GND
5
R7 33n(M) 33n(M) 6
6K2 +VCC
AFL-R
SW36C
PS-42E85L 7 SOLO(PFL) AUX-3
R8 R381 VR76 R382 8
VR75B 6K2 5K6 B50K 5K6 C278 R452
500KC R432 9
GND
LO (80Hz) 2.2u/50V 6K8 1K5
R218
VR47
SW35A J10 5K6 W50K
R58 SW37C PS-22E85L 1
LD58 PS-42E85L 7 2 POST
YEL 10K GND
8 3 GND
(SOLO) R428 LD59 9 SW35B AUX-1
-VCC 4K7 RED PS-22E85L 4 (PRE)
10 R368
R416 TR28 PEAK 5 R121
11 2K2 6 VR77
A GND 33K BC847 5K6 A
12 LOGIC
LOGIC
W50K
D15 AUX2 PRE/POST
SW37D TR27 AUX-2
BAS316 (LOGIC=2.0V or 0.5V) BC847
PS-42E85L GND
R164
VR78
5K6 W50K
PGND

GND

DRW G.BOCCATO DWG# 550781 PCB# RD122MN1 GENERALMUSIC S.p.A. ITALY

CKD G.RICCI DATE: 22/06/2004 ALL RIGHTS ARE RESERVED, NO COPIES

APP. N.ZAVATTA REV: A

MAIN BOARD (part 2 of 7) OR REPRODUCE THIS DOCUMENT WITHOUT
WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8

7
 1 2 3 4 5 6 7 8

SKK768195 - RD122FX MAIN BOARD ASSEMBLY (part 3 of 7)

SKK768196 - RD122 MAIN BOARD ASSEMBLY (part 3 of 6)

D D

EQ HI (12K) R412
SW39:MUTE/ALT3-4
C38 C162 VR81 C274 C283 VR87A SW40:SOLO,PFL
VR82
47u/25V B50K MID (FREQ=100Hz-8K) 6.8n(M) B50K 6.8n(M) C107 22P 1K JQ10K PAN SW39A
22P R113 PS-42E85L 1
RTN-CH7 3K3
RTN-CH7 LEFT-BUS
C105 R396 R109 R457 2
22P 5K1 12K C75 R414 VR87B 3
ALT-3
1M 2 47u/25V
R53 R55 R26 1K JQ10K SW39B
10K C73 1 R120
10K 6 3K9 3 PS-42E85L 4
C13 47u/25V 3K3 RIGHT-BUS
6.8n(M) 7 6 GND U45A 5
5 7 4580M 6
ALT-4
5 VR88A R522
R167 15K GND SW40A
5K1 U44B R65 10KD R463 PS-42E85L 1
4580M U45B LEVEL 20K GND
VR83A R31 3 10K GND 4580M 2
500KC 3K 1 3
AFL-L
2 GND
U44A GND R464 SW40B
GND C94 4580M PS-42E85L 4
152(M) C138 C139 20K GND
5
R11 33n(M) 33n(M) 6
6K2 +VCC
AFL-R
SW39C
PS-42E85L 7 SOLO(PFL) AUX-3
R12 R385 VR84 R386 8
VR83B 6K2 5K6 B50K 5K6 C279 R453
500KC R433 9
GND
LO (80Hz) 2.2u/50V 6K8 1K5
R220
VR49
SW38A J11 5K6 W50K
LD61 R67 SW40C PS-22E85L 1
PS-42E85L 7 2 POST
YEL 10K GND
8 3 GND
(SOLO) R429 LD62 9 SW38B AUX-1
-VCC 4K7 RED PS-22E85L 4 (PRE)
10 R369
R417 TR30 PEAK 5
11 2K2 6 VR85
GND 33K BC847 R172
12 LOGIC
LOGIC
W50K
C D16 AUX2 PRE/POST 5K6 C
TR29 AUX-2
SW40D BAS316 (LOGIC=2.0V or 0.5V) BC847 R173
PS-42E85L GND
5K6
VR86
W50K
PGND

GND

EQ HI (12K) SW42:MUTE/ALT3-4
C77 C167 C276 C284 R425 VR95A SW43:SOLO,PFL
VR90 VR89
47u/25V B50K MID (FREQ=100Hz-8K) 6.8n(M) B50K 6.8n(M) C111 22P 1K JQ10K PAN SW42A
22P R170 PS-42E85L 1
RTN-CH8 3K3
RTN-CH8 LEFT-BUS
C110 R398 R169 R458 2
22P 5K1 12K C79 R426 VR95B 3
ALT-3
1M 2 47u/25V
R63 R64 R34 1K JQ10K SW42B
10K C78 1 R171
10K 6 3K9 3 PS-42E85L 4
C18 47u/25V 3K3 RIGHT-BUS
6.8n(M) 7 6 GND U47A 5
5 7 4580M 6
ALT-4
R168
5 VR96A R525
U46B 10KD 15K GND R465 SW43A
5K1 R66 PS-42E85L 1
U47B 20K
VR91A R33 3
4580M 10K GND LEVEL 2
GND
3K 4580M
500KC 1 3
AFL-L
2 GND
U46A GND R466 SW43B
GND C95 4580M PS-42E85L 4
152(M) C142 C143 20K GND
5
R15 33n(M) 33n(M) 6
6K2 +VCC
AFL-R
SW42C
PS-42E85L 7 SOLO(PFL) AUX-3
R16 R389 VR92 R390 8
VR91B 6K2 5K6 B50K 5K6 C280 R454
B 500KC R434 9
GND B
LO (80Hz) 2.2u/50V 6K8 1K5
R224
VR51
SW41A J12 5K6 W50K
LD64 R68 SW43C PS-22E85L 1
YEL PS-42E85L 7 2 POST
10K GND
8 3 GND
(SOLO) R430 LD65 9 SW41B AUX-1
-VCC 4K7 RED PS-22E85L 4 (PRE)
10 R370
R418 TR32 PEAK 5
11 2K2 6 VR93
GND 33K BC847 R174
12 LOGIC
LOGIC
W50K
D17 AUX2 PRE/POST 5K6
TR31 AUX-2
SW43D BAS316 (LOGIC=2.0V or 0.5V) BC847 R175
PS-42E85L 5K6 GND
VR94
W50K
PGND

GND

C301 C303 C305 C307

100N 100N 100N 100N
+VCC
8 8 8 8
U44C U45C U46C U47C
4580M 4580M 4580M 4580M
A A
4 4 4 4
-VCC
C302 C304 C306 C308
100N 100N 100N 100N
GND

DRW G.BOCCATO DWG# 550782 PCB# RD122MN1 GENERALMUSIC S.p.A. ITALY

CKD G.RICCI DATE: 23/06/2004 ALL RIGHTS ARE RESERVED, NO COPIES

APP. N.ZAVATTA REV: A

MAIN BOARD (part 3 of 7) OR REPRODUCE THIS DOCUMENT WITHOUT
WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8

8
 1 2 3 4 5 6 7 8

SKK768195 - RD122FX MAIN BOARD ASSEMBLY (part 4 of 7)

C158
VR29A
B50K EQ HI (12KHz) C341
3.3n(M) SW15D
LD14
YEL
22P SKK768196 - RD122 MAIN BOARD ASSEMBLY (part 4 of 6)
PS-42E85L (SOLO) R254
C112 R486 R488 -VCC R190 18K
22P 1K8 1K8 R83 5K1 C10 SW14:MUTE/ALT3-4
R69 10 2 47u/25V
10K 11 2K2 1
SW15:SOLO,PFL
VR30A C114 12 LOGIC 3
22P LOGIC R439
R467 B50K D3 GND U6A 1K R192 SW14A
C333 PS-42E85L 1
1n(M) R475 12K HI-MID(3KHz) R401 BAS316 4580M 5K6 LEFT-BUS
GND (LOGIC=2.0V or 0.5V) R511 2
220K 1M
D PRE-CH9
PRE-CH9 2 15K BAL 3
ALT-3 D
1 R399 R98
R515 3
C349 VR34A SW14B
C80 220K C325 1M 3.3n(M) 18K R193
47u/25V 6 JQ10K PS-42E85L 4
12n(M) C159 5K6 RIGHT-BUS
GND U5A 7 5
5 GND
22P 6
R523 4580M R419 GND
ALT-4
47K C6
R483 22K VR101A R435 R437 GND U5B R191 R251 R97 R270 SW15A
MID-LO(500Hz) 47u/25V PS-42E85L 1
1K8 B50K 6K8 6K8 4580M VR35B 5K1 18K 18K R440 47K GND
6 1K 2
10KD*2 7 3
R485 R94 LEVEL AFL-L
VR31A C357 4K7 5
C317 1K8 B50K GND GND SW15B
12n(M) 47n(M) C9 R271 PS-42E85L 4
LO(80Hz) U6B
R512 4580M
47u/25V 47K
5
GND
VR34B
15K JQ10K 6
AFL-R
+VCC
SW14C
VR29B PS-42E85L 7
B50K EQ HI (12KHz) C342 R95
8
3.3n(M) 4K7 9 GND
GND
GND R287
C113 R487 R489 VR35A SW15C 120R 1/4W
1K8 +VCC R96
R70 22P 1K8 10KD*2 PS-42E85L 7 SOLO(PFL)
10K GND
10K
C115 LEVEL 8
AUX-3
VR30B GND R177 9 R286
B50K 22P 1K5
C334 R468 510R
1n(M) R476 12K HI-MID(3KHz) R402
C145 R32
VR52 CR-A
TR19
2.2u/50V 6K8 SW13A J5 R448 BC857
PRE-CH10 2 220K 1M PS-22E85L 1 W50K
PRE-CH10
1 2 POST 4K7
R516 R400 C350 AUX-1
C81 220K C326 3 1M 3
3.3n(M) 6 SW13B GND
47u/25V R155
12n(M) GND 7 PS-22E85L 4 (PRE) SW17D
U48A 4K7 VR32 PS-42E85L 10
4580M
5 TR4 5
R524 R420 BC847 LD15 6 R194 W50K 11
47K C8 R145 4K7 LD16 CH11/12
R484 22K VR101B R436 R438 GND U48B RED 12 GR
MID-LO(500Hz) 47u/25V AUX2 PRE/POST
1K8 B50K 6K8 6K8 4580M 33K TR3 PEAK AUX-2
BC847 GND
R195 SW14D
R498 4K7 PS-42E85L 10
VR31B C359 VR33
C C319 1K8 B50K 11 C
12n(M) 47n(M) W50K LD13 CH9/10
PGND 12
LO(80Hz) GR

GND

C164 SW42D
22P PS-42E85L 10
VR36A R258 11
B50K EQ HI (12KHz) C345 LD17 12
LD63 CH8
3.3n(M) SW18D YEL R203 18K GR
(SOLO) 5K1 C23
PS-42E85L 2 47u/25V
C120 R500 R502 -VCC SW39D
1K8 1 SW17:MUTE/ALT3-4
R74 22P 1K8 10 R85 3 PS-42E85L 10
10K 11 2K2 GND U8A SW18:SOLO,PFL 11
VR37A C122 LD60 CH7
12 LOGIC 4580M R441 12 GR
B50K 22P LOGIC
R513 SW17A
C337 D5 1K R205
R471 HI-MID(3KHz) BAS316 15K PS-42E85L 1
1n(M) R479 R409 5K6 LEFT-BUS SW36D
12K GND (LOGIC=2.0V or 0.5V) 2
220K 1M PS-42E85L 10
PRE-CH11
PRE-CH11 2 BAL 3
ALT-3
R519 1 R407 R108 11 LD57 CH6
3
C353 VR41A SW17B 12
C84 220K C329 1M 3.3n(M) 18K R206 GR
47u/25V 6 GND JQ10K PS-42E85L 4
12n(M) C165 5K6 RIGHT-BUS
GND U7A 7 5
5
22P 6 SW33D
R527 4580M R423 GND
ALT-4 PS-42E85L 10
47K C19
R497 22K VR102A R443 R444 GND U7B R204 R257 R107 R274 SW18A 11 LD54 CH5
MID-LO(500Hz) 47u/25V PS-42E85L 1
1K8 B50K 6K8 6K8 4580M VR42B 5K1 18K 18K R442 47K GND
12 GR
6 1K 2
10KD*2 7 3 (MUTE/ALT3-4)
R499 R104 LEVEL AFL-L
VR38A C360 4K7 5
C320 1K8 B50K GND GND SW18B
12n(M) 47n(M) C22 R275 PS-42E85L 4
LO(80Hz) U8B
R514 4580M
47u/25V 47K
5
GND SW11D
VR41B PS-42E85L 10
15K SW17C JQ10K 6
PS-42E85L 7 AFL-R
11 LD10 CH4
VR36B 8 12
B50K EQ HI (12KHz) C346 R105
9
GR
3.3n(M) 4K7 GND
GND
B B
R501 GND SW18C
R106 PS-42E85L SW8D
C121 R503 VR42A 7
SOLO(PFL) PS-42E85L 10
R75 22P 1K8 1K8 10KD*2 10K GND
+VCC 8 11 LD7
AUX-3
10K
C123 LEVEL 9 12 GR CH3
VR37B GND
B50K 22P R179
C338 R472
1n(M) R480 12K HI-MID(3KHz) R410
C147 R40 1K5 SW16A J6 R449
VR53 SW5D
PS-42E85L 10
2.2u/50V 6K8 PS-22E85L 1 W50K
PRE-CH12 2 220K 1M 2 POST 4K7 11
PRE-CH12 AUX-1 LD4 CH2
R520 1 R408 3 12 GR
3
C354 SW16B GND
C85 220K C330 1M 3.3n(M)
47u/25V 6 R157 PS-22E85L 4 (PRE)
12n(M) GND 7 5 VR39 SW2D
U49A 4K7 R207 PS-42E85L 10
5 TR8 6 W50K
R528 4580M R424 4K7
C21 R147 BC847 LD18 AUX2 PRE/POST
11 LD1
R505 22K 47K R447 GND RED 12 CH1
VR102B R445 U49B 47u/25V AUX-2 GR
1K8 B50K MID-LO(500Hz) 6K8 6K8 4580M 33K TR7 PEAK R208 GND
BC847 (MUTE/ALT3-4)
4K7
VR40
R507 VR38B C362 W50K -VCC
C322 1K8 B50K
12n(M) 47n(M)
PGND
LO(80Hz)
GND

C309 C311 C205 C207 C209 C211

100N 100N 100N 100N 100N 100N
+VCC
8 8 8 8 8 8
U48C U49C U5C U6C U7C U8C
4580M 4580M 4580M 4580M 4580M 4580M
A A
4 4 4 4 4 4
-VCC
C310 C312 C206 C208 C210 C212
100N 100N 100N 100N 100N 100N
GND

DRW G.BOCCATO DWG# 550783 PCB# RD122MN1 GENERALMUSIC S.p.A. ITALY

CKD G.RICCI DATE: 23/06/2004 ALL RIGHTS ARE RESERVED, NO COPIES

APP. N.ZAVATTA REV: A

MAIN BOARD (part 4 of 7) OR REPRODUCE THIS DOCUMENT WITHOUT
WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8

9
 1 2 3 4 5 6 7 8

C218
22P
C367
C176 R342 MAIN OUT 22P C263
22P
C42
10K
(BALANCED) 22P
R229 47u/25V
R332
10K C60 MAIN MIX
C179
C43 AUX RETURN 1 R292
5K1 U10B 22P R531 R532
6 47u/25V LEFT MAIN-L-3 10K 10K R131 VR58A 56K
MAIN-L-3
7
MAIN-INS-L AUX-RTN1-L
AUX-RTN1-L 2 8K2 W50K R236
6 5 C251 47u/25V 1 2
LEFT-BUS R265 22P R128 5K1
7 4580M C259 C365 3 1 LEFT-BUS
5
MAIN-RTN-L R230 18K
R234
10K LEFT 100P 47u/25v U52A C45 R288
3
LEFT-BUS
5K1 R232 4580M 47u/25V U20A C47
GND GND 2 5K1 5K1 22K
U13B C368 4580M 47u/25V
4580M 1 6 GND
D VR62A 3 7 MAIN-L-2 GND GND 22P D
C219 MAIN-L-2 C264
10KD*2 U14A 5 GND GND GND
22P
22P C253
4580M R129
GND GND U14B 47u/25V 10K R533 R534 R293
C177 R343
10K
GND 4580M 10K 10K R130 VR58B 56K
22P AUX-RTN1-R 6 8K2
C41 AUX-RTN1-R W50K
R334 7 R237
R228 47u/25V C215
5K1 10K C178 GND C260 C366 5 6 5K1
2 U10A
1
47u/25V MAIN MIX 22P
C44
MAIN-R-3
100P 47u/25V U52B
4580M
C46
R289 5
7 RIGHT-BUS RIGHT-BUS
MAIN-INS-R RIGHT MAIN-R-3 47u/25V
RIGHT-BUS
2 3 22K C48
1 4580M C252 47u/25V U20B
R264 22P R127 47u/25V
3 GND GND 4580M
MAIN-RTN-R
R231
18K
R235
10K RIGHT GND GND GND
GND U13A GND 5K1 R233
2 5K1 5K1 C371
4580M 22P
1 6 GND C265
VR62B 3 7 MAIN-R-2 22P
MAIN-R-2
10KD*2
U15A
5
C255
AUX RETURN 2 R294
R132 R535 R536
GND GND 4580M U15B 47u/25V 10K R133 VR57A 56K
AUX-RTN2-L
10K 10K
GND 4580M AUX-RTN2-L
2 8K2 W50K
1 2
C261 C369 3 1 LEFT-BUS LEFT-BUS
C180 C183 GND U53A C53 3
100P 47u/25V
22P
C50 ALT 3-4 22P 4580M 47u/25V R290 U21A C55
R326
5K1
(ALT-3) 22K
R241 47u/25V C372 4580M 47u/25V
5K1 R302 22P
GND GND
R299 18K GND GND GND
C266
ALT-3
2
1
5K6
2
ALT 3/4 OUT 22P
R537 R538 R295
3 1
ALT3-L 10K 10K R134 VR57B 56K
VR59A 3 AUX-RTN2-R 6 8K2 W50K
SW27A AUX-RTN2-R
GND U16A 10KD*2 C254 R307 7
47u/25V PS-22E85L C262 5 6
4580M U17A 5K6 GND C370
GND GND 100P 47u/25V U53B C54 7 RIGHT-BUS RIGHT-BUS
4580M 4580M 47u/25V R291 5
LEFT-BUS R325
R375 22K C56
C (ALT3/4 TO MIX) U21B 5K1 C
10K 47u/25V
GND GND 4580M
C181 GND GND GND
22P C182 C117
C49 22P GND SW27B R491 22P
R240 R308 PS-22E85L
47u/25V
5K1 R301
18K
5K6 GND 10K AUX RETURN 3
R300 GND R159 C33 C116
RIGHT-BUS 22P
6 5K6 10K 47u/25V
ALT-4
7 6 2
5 7 1 R283
VR59B ALT4-R R225
5
AUX-RTN3-L
AUX-RTN3-L 3 12K
GND U16B 10KD*2 C256 R376 U51A R181 5K1
4580M 47u/25V C351 C31 4580M 2
GND GND U17B 10K 6K2 1 LEFT-BUS
100P 47u/25V LEFT-BUS
4580M 3
R151 GND R226
U54A C34 5K1
GND 15K
GND R526 4580M 47u/25V
VR43A 15K
10KD*2
SKK768195 - RD122FX MAIN BOARD ASSEMBLY (part 5 of 7) GND C118
R183
6K2 GND
R492 22P C87
C187
22P SKK768196 - RD122 MAIN BOARD ASSEMBLY (part 5 of 6) 10K GND 22P
C184 R296
AUX1 SEND R306 GND 12K
22P R161
36K 10K R227
6 5K1
R303 7 6
33K 6
AUX-RTN3-R
AUX-RTN3-R 5 7 RIGHT-BUS RIGHT-BUS
7 AUX-SEND1 U51B C40 5
AUX-SEND1 R239
AUX-1
2 5 C352 C39 4580M 47u/25V GND C51
1 VR60 C61 100P U54B 5K1
R136 47u/25V 47u/25V
3 W50K 47u/25V 10K R529 4580M
C58 R297 U18B R149 VR43B 15K
GND U18A 47u/25V 5K6 GND 4580M 15K 10KD*2
4580M GND
2TK TO CR-L
GND
C188
B GND
R494 22P
GND AUX3/DSP TO MONITOR B
GND
C186
22P 20K R314 2TK TO MIX GND
R238
AUX-1

C185 22K C65 SW28A 5K1

GND
22P AUX2 SEND R305
36K
C63 6
47u/25V PS-22E85L
GND
VR55
47u/25V 7 W50K
R304 2TK-IN-L 5
2TK-IN-L R242 LEFT-BUS
33K 6
7 AUX-SEND2 R311 U22B R137 3K9 GND
2 5
AUX-SEND2 C267 20K R495 4580M 10K
AUX-2 100P
1 VR61 C62 R135 15K
3 W50K 47u/25V GND
R298 U19B 10K GND
C57
GND U19A 47u/25V 5K6 GND 4580M
4580M
GND GND
GND
C189
R493 22P 2TK TO CR-R
C124
22P 20K R313
C119
22P
AUX3 SEND R482 C64
GND 22K C66
47u/25V
SW28B
2 PS-22E85L
36K 47u/25V 1
GND
R481 2TK-IN-R R312 3
2TK-IN-R R243 RIGHT-BUS
33K 6 20K
7 AUX-SEND3 U22A R138 3K9
AUX-SEND3
AUX-3
2 5 C268 R496 4580M 10K
1 VR54 C37 R214 100P 15K
3 W50K 47u/25V GND
R490 U50B 10K GND
C35
GND U50A 47u/25V 5K6 GND 4580M
4580M
GND GND
GND

A C375 C373 C223 C225 C227 C229 C231 C233 C235 C237 C239 C241 C318 C313 C315 C222 A
100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N
+VCC 8 8 8 8 8 8 8
8 8 8 8 8 8 8 8 8
U53C U52C U13C U14C U15C U16C U17C U18C U19C U20C U21C U22C U54C U50C U51C U10C
4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M 4580M
4 4 4 4 4 4 4 4 4 4 4 4 4 4 4 4
-VCC
C376 C374 C224 C226 C228 C230 C232 C234 C236 C238 C240 C242 C321 C314 C316 C323
100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N 100N
GND
DRW G.BOCCATO DWG# 550784 PCB# RD122MN1 GENERALMUSIC S.p.A. ITALY
CKD G.RICCI DATE: 23/06/2004 ALL RIGHTS ARE RESERVED, NO COPIES

APP. N.ZAVATTA REV: A

MAIN BOARD (part 5 of 7) OR REPRODUCE THIS DOCUMENT WITHOUT
WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8

10
 1 2 3 4 5 6 7 8

C190
22P
R139
10K CTRL ROOM SOURCE
C67 SW-FET C193
47u/25V SW-FET 22P
SOLO(PFL) 2
SOLO(PFL)
1 C69
SW29A R319 47u/25V C194
3 R327 22P
PS-22E85L 20K
12K CONTROL
GND U25A R315 R140 R245
20K MAIN-L-2
2 ROOM
4580M 5K6 VR64B 20K
MAIN MIX 1
TR20 3 W50K C393
D C191 C216 SW30A J112 D
GND R317 PS-22E85L 2 47u/25V
22P 22P GND U23A 1 CTRL-R-L
20K CTRL-R-L
ALT3-L R328 4580M R335 3
R284 R163 U24A
30K SW26B 10K 12K 100K
C68 PS-42E85L R143 U11A C36 ALT-3 4580M R266
4 R244 PFL-IN-L GND GND 10K
AFL-L 6 47u/25V 5 10K 2 47u/25V SW31A PFL-IN-L
AFL-L R318 PS-22E85L 5K1
7 6 1 PFL-IN-L 10K R152
PFL-IN-L R331
5 3 47K GND
2TK TO CR-L 62K
GND R316 4580M
U25B 20K 2TK L-METER
4580M **SW26:SOLO MODE
GND GND GND GND
C192
22P
GND C217
22P SW-FET
SW-FET TR21
J112
SKK768195 - RD122FX MAIN BOARD ASSEMBLY (part 6 of 7)
R285
30K SW26C
R282
10K
SKK768196 - RD122 MAIN BOARD ASSEMBLY (part 6 of 6)
C70 PS-42E85L R162 C59
7 U11B
AFL-R 6 47u/25V 8 10K 6 47u/25V SW-FET C196
AFL-R SW-FET 22P
7 9 7 PFL-IN-R PFL-IN-R
5 5 C71
SW29B R324 47u/25V C195
R320 R329 PS-22E85L 20K 22P
GND U26B 4580M 12K
20K
4580M GND
MAIN-R-2
6 R249
MAIN MIX TR22 7 20K
GND 5 VR64A R267
SW30B J112 R570 6
R322 PS-22E85L W50K 10K
20K GND U23B 5K6 7 CTRL-R-R
CTRL-R-R
R330 4580M 5
SW26A ALT4-R R338
LD27 12K 100K C394
PS-42E85L ALT-4 U24B 47u/25V
1 PFL PFL-IN-R GND GND
2 SW31B R248 PFL-IN-R 4580M
GND GR R323 PS-22E85L 5K1
+VCC +VCC 3 10K
R333 R153 GND
RED SOLO 2TK TO CR-R 47K
62K
C R336 R341 ACTIVE R247 C
100K 220K U26A 2TK
LD26 5K1
R142 4580M R246 SW-FET
SW-FET
GND GND GND

LOGIC 10K 3 5K1 SW-FET TR23

LOGIC R321 C270 SW-FET J112
1 2.2u/50V
2 20K
R141 D11
R339 10K BAS316 SW26D CN2 CN3 CN4
PS-42E85L GND GND 12P2.0 12P2.0 12P2.0
15K R340 10 TR24

FROM CHANNELS I/O BOARD CN7

FROM CHANNELS I/O BOARD CN3
15K

TO CHANNELS I/O BOARD CN4

11 J112
12 R337 R-METER RTN-CH1
RTN-CH1 1 PRE-CH9
PRE-CH9 1 EFXRTN-L
EFXRTN-L 1
GND GND C269 D12 RTN-CH2 PRE-CH10 EFXRTN-R
100K RTN-CH2
RTN-CH3
2 PRE-CH10
PRE-CH11
2 EFXRTN-R 2
100N BAS316 RTN-CH3 3 PRE-CH11 3 3
RTN-CH4
RTN-CH4 4 PRE-CH12
PRE-CH12 4 AUX-SEND1
AUX-SEND1 4
RTN-CH5
RTN-CH5 5 5 AUX-SEND2
AUX-SEND2 5
GND
RTN-CH6
RTN-CH6 6 AUX-RTN1-L
AUX-RTN1-L 6 AUX-SEND3
AUX-SEND3 6
RTN-CH7
RTN-CH7 7 AUX-RTN1-R
AUX-RTN1-R 7 CTRL-R-L
CTRL-R-L 7
RTN-CH8 AUX-RTN2-L CTRL-R-R
RTN-CH8 8 AUX-RTN2-L 8 CTRL-R-R 8
PH PWR 9 AUX-RTN2-R
AUX-RTN2-R 9 2TK-IN-L
2TK-IN-L 9
AUX-RTN3-L 2TK-IN-R
LEFT METER +VCC 10 AUX-RTN3-L
AUX-RTN3-R 10 2TK-IN-R
MAIN-L-2 10
11 AUX-RTN3-R 11 MAIN-L-2 11
(-30) (-20) (-10) (-7) (-4) (-2) (0) (+2) (+4) (+7) (+10) (+18) MAIN-R-2
-VCC 12 12 MAIN-R-2 12
TR13 LD41 LD40 LD39 LD38 LD37 LD36 LD35 LD34 LD33 LD32 LD31 LD30
+VCC R350 BC857 GR GR GR GR GR GR GR GR GR YEL YEL RED
120R 1/4W -VCC +VCC GND GND GND

R252
14

14

14

14

14

14
U31B U31C U33B U33C U35B U35C
1

1
U30B U30C U32B U32C U34B U34C 2K
LM339 LM339 LM339 LM339 LM339 LM339 LM339 LM339 LM339 LM339 LM339 LM339
LD29 CN6
GR 14P2.0
R351
7

8
510R PWR ON CN1
FOOTSW PH PWR -VCC +VCC +5VD 2.5-8P

FROM SUPPLY BOARD CN3

D1A D1B FOOTSW 1
B +VCC PGND ALT3-L B

TO REAR I/O BOARD CN2

ALT3-L 2 1
ALT4-R
CR-A PGND ALT4-R 3 2
CTRL-R-L
CTRL-R-L 4 3
R354 R355 R356 R359 R357 R360 R358 R361 R362 R363 R364 R365 R366 PH PWR CTRL-R-R
DA204K 100R 120R 470R 330R 470R 330R 470R 510R 620R 1K3 2K 5K6 8K2 CTRL-R-R 5 4
MAIN-RTN-L
MAIN-RTN-L 6 5
R87 MAIN-INS-L
MAIN-INS-L 7 6
10K MAIN-RTN-R
MAIN-RTN-R 8 7
R352 R253 MAIN-INS-R
MAIN-INS-R 9 8
510R MAIN-R-2
4K7 MAIN-R-2 10
11

10

11

10

11

10

11

10

11

10

11

10
MAIN-R-3
4

4
5

MAIN-R-3 11
PGND
MAIN-L-2
MAIN-L-2 12
GND PGND DGND
LD28 MAIN-L-3
U30A U30D U31A U31D U32A U32D RED MAIN-L-3 13
U33A U33D U34A U34D U35A U35D 14
LM339 LM339 LM339 LM339 LM339 LM339 LM339 LM339 LM339 LM339 LM339 LM339 PHANTOM
13

13

13

13

13

13
GND
2

R353
120R 1/4W -VCC PGND

TR14
BC857 LD53 LD52 LD51 LD50 LD49 LD48 LD47 LD46 LD45 LD44 LD43 LD42
GR GR GR GR GR GR GR GR GR YEL YEL RED

D13
RLS4148 D14
C213 R373 C243 C245 C247 C249 C220
RLS4148 100N 47R +VCC 100N 100N 100N 100N 100N
+VCC
2 6 8 8 8 8 8
L-METER
1 7 U23C U24C
3 5 8 3 3 3 3 3 3 C257 U25C U26C U11C
47u/25V 4580M 4580M 4580M 4580M 4580M
U27A D21 U27B D22 U27C U30E U31E U32E U33E U34E U35E 4 4 4 4 4
GND 4580M RLS4148 GND 4580M RLS4148 4580M LM339 LM339 LM339 LM339 LM339 LM339
-VCC
4 12 12 12 12 12 12 PGND
C258 C244 C246 C248 C250 C221
R504 R344 R345 47u/25V 100N 100N 100N 100N 100N
A 100K C271 R348 100K C272 R349 GND A
36K 47u/25V 6K8 47u/25V 6K8
C214 R374 -VCC
100N 47R
PGND PGND PGND PGND
GND
R-METER
R506
36K
DRW G.BOCCATO DWG# 550785 PCB# RD122MN1 GENERALMUSIC S.p.A. ITALY
CKD G.RICCI DATE: 24/06/2004 ALL RIGHTS ARE RESERVED, NO COPIES

GND
APP. N.ZAVATTA REV: A
MAIN BOARD (part 6 of 7) OR REPRODUCE THIS DOCUMENT WITHOUT
WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8

11
 1 2 3 4 5 6 7 8

+5VD
10K CHANGE TO 3K3

2
4
6
8

2
4
6
8
D 2/13 change to 5K6 D
C332 R72 AR1 AR2 Unused gates
C52 1.5nF 2.5% 10K 680R*4 680R*4
22P
U57B U56D
TO EFX BOARD CN2 EN1 EN2 74HC109 74HC14
+5VD CN5 SDB161PVB15FS SDB161PVB15FS 10 14 8 9

1
3
5
7

1
3
5
7
Q J
R71 1 1 1 1
R261 R73 HEADER 8X2
5K6 R56 10K 10K 2 2 COM 2 2 COM
CLK
12
C327 R450 6 3 4 3 4 U56F
10K 2 1 74HC14
4.7uF/25V 68R 2 7 4 8 4 8 9 13
4 3 Q K

R
S
EFXRTN-L 1 5 12 13
EFXRTN-L C339 6 5
4

11

15
U59B 33P 8 7 VARIATION DGND PRESET DGND
U59A 10 9
4580M 4580M DGND DGND
RL1C 12 11
GND GND GND
RY-5W-K 14 13
(MUTE) C336 16 15 U56E
R115
8

C83 1.5nF 2.5% 10K 10 11

GND 22P
GND
74HC14 DGND
U56B U56C +5VD
R262 R114 R117
R77 10K 3 4 5 6
C331 R469 5K6 10K
10K 6
4.7uF/25V 68R 2 7 R280
EFXRTN-R 1 5 74HC14 74HC14 U55A 47K
EFXRTN-R C340
3

3 NE555
U60A U60B 33P 3 4
4580M OUT RS
C 4580M C
RL1B GND GND GND 2
RY-5W-K TG

CTR
(MUTE) 6

DS
7

TH
C335
C82 1.5nF R90 C86
GND 2.5% 10K

7
22P 22P
R260 R116
C328 2K2 10K
4.7uF/25V R76
10K
C125 C343
AUX-SEND3 2 100N 10uF/16V
AUX-SEND3
1 6
3 7 DGND DGND
R88 5
U61A 10K U61B
GND 4580M GND 4580M +5VD DGND DGND

TR12 R123

1
R263 R50 BC847
+VCC 10K
1M 7K5 RL1A
RY-5W-K C127 R124
R125
D18A 100N 10K +5VD +5VD
MUTE(GLOW) LD19 10K

2
C126 R470 RB400D
PEAK(FLICKER) RED 2M2 D9
100N D20 U57A
RLS4148 R122 R126 BAS316
74HC109 D7 10K
R281 TR11 10K 6 2
BC847 Q J BAS316 R474
4K7 5
220R
B 3 7
CLK
4 2 1 FOOTSW FOOTSW
B
1 6 R118
2 R446 10K 7 3 R477
U58B Q K U56A

R
S
1K 74HC14 220R SW19A
U58A LM393 R473 R478 1 PS-22E85NL

1
LM393 220R 820K D19 DGND DGND 2
DA202K C347 C348 3
1uF/50V 1uF/50V SW19B
DGND 4 PS-22E85NL
DGND DGND DGND 5
DGND DGND 6
(MUTE)
DGND

C149 C166 C173 C175 +5VD

+VCC
8
100N
8
100N
8 8 8 16
100N
14
100N
SKK768195 - RD122FX MAIN BOARD ASSEMBLY (part 7 of 7)
U59C U60C U61C U58C U55B U57C U56G C344 (RD122FX only)
4580M 4580M 4580M LM393 NE555 HC109 74HC14 220uF/16V
4 4 4 4 1 8 7
JP1
-VCC
C151 C172
100N 100N DGND PGND
GND

A A

DRW G.BOCCATO DWG# 550786 PCB# RD122MN1 GENERALMUSIC S.p.A. ITALY

CKD G.RICCI DATE: 24/06/2004 ALL RIGHTS ARE RESERVED, NO COPIES

APP. N.ZAVATTA REV: A

MAIN BOARD (part 7 of 7) OR REPRODUCE THIS DOCUMENT WITHOUT
WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8

12
13
 1 2 3 4 5 6 7 8

SKK768192 - RD122FX REAR IN/OUT BOARD ASSEMBLY

SKK768193 - RD122 REAR IN/OUT BOARD ASSEMBLY

R3 R6
D INSERT1 INSERT5 120R ALT-3 (LEFT) 120R D
RTN-CH1 R 3c RTN-CH5 R 3c R 3c R 3c
INS-CH1 RN 4d INS-CH5 RN 4d RN 4d RN 4d
TN 2b TN 2b TN 2b TN 2b
T 1a T 1a ATL3-L T 1a T 1a MAIN R (UNBAL)
R1 S 5e R25 S 5e R4 S 5e R7 S 5e
120R 120R 120R 120R
X1 X11 X5 X8
GND-INS JY-6351G-02-250 GND-INS JY-6351G-02-250 JY-6351G-02-250 JY-6351G-02-250

INSERT2 R2 R5
RTN-CH2 R 3c INSERT6 120R ALT-4 (RIGHT) 120R
INS-CH2 RN 4d RTN-CH6 R 3c R 3c R 3c
TN 2b INS-CH6 RN 4d RN 4d RN 4d
T 1a TN 2b TN 2b TN 2b
T 1a ATL4-R T 1a T 1a MAIN L (UNBAL)
R8 S 5e
120R R26 S 5e R10 S 5e R11 S 5e
X2 120R 120R 120R
GND-INS JY-6351G-02-250 X12 X6 X7
GND-INS JY-6351G-02-250 JY-6351G-02-250 JY-6351G-02-250

INSERT3
RTN-CH3 R 3c INSERT7
C
INS-CH3 RN 4d
TN 2b
RTN-CH7
INS-CH7
R 3c
RN 4d
FOOTSWITCH R13
120R
C
T 1a TN
T
2b
1a
3c
4d
MAIN-R-2
MAIN OUT
R9
120R
S 5e
R27 S 5e FOOTSW
2b
1a MAIN-R-3
R14
120R
2
3
(BALANCED)
X3 120R 1
GND-INS JY-6351G-02-250 X13 5e RIGHT
GND-INS JY-6351G-02-250 R15 R16
GND X18 5K1 5K1 X10
JY-6351G-02-250 JY-5030-030G
INSERT4
RTN-CH4 R 3c INSERT8
INS-CH4 RN 4d RTN-CH8 R 3c
TN 2b INS-CH8 RN 4d
CTRL ROOM OUT
R17
T 1a TN 2b R23 120R
T 1a MAIN-L-2
R12 S 5e 120R 3c
120R R28 S 5e 4d R18 2
X4 120R 120R
2b MAIN-L-3 3
GND-INS JY-6351G-02-250
GND-INS
X14
JY-6351G-02-250
CTRL-R-L 1a LEFT 1
LEFT
R24 5e R19 R20
120R 5K1 5K1 X9
X25 JY-5030-030G
JY-6351G-02-250

R29
B 120R B
3c
4d
2b MAIN-INSERT
CTRL-R-R 1a RIGHT
MAIN-RTN-L R 3c
R30 5e MAIN-INS-L RN 4d
120R TN 2b
X26 T 1a MAIN-INS-L
JY-6351G-02-250
R21 S 5e
120R
X15
JY-6351G-02-250
FROM CHANNELS IN/OUT BOARD CN1

FROM CHANNELS IN/OUT BOARD CN6

CN1 CN3 CN2

9P-2.0 9P-2.0 14P-2.0

RTN-CH1 RTN-CH5 FOOTSW MAIN-RTN-R R 3c

1 1 1
INS-CH1 INS-CH5 ATL3-L MAIN-INS-R RN 4d
2 2 2
RTN-CH2 RTN-CH6 ATL4-R TN 2b
FROM MAIN BOARD CN6

3 3 3
4
INS-CH2
4
INS-CH6
4
CTRL-R-L T 1a MAIN-INS-R
RTN-CH3 RTN-CH7 CTRL-R-R
5 5 5 R22
INS-CH3 INS-CH7 MAIN-RTN-L S 5e
6 6 6 120R
RTN-CH4 RTN-CH8 MAIN-INS-L
7 7 7 X16
INS-CH4 INS-CH8 MAIN-RTN-R
8 8 8
9 9 9
MAIN-INS-R JY-6351G-02-250
MAIN-R-2
10
MAIN-R-3
11
A MAIN-L-2 A
12
GND-INS GND-INS MAIN-L-3
13
14

DRW G.BOCCATO DWG# 550779 PCB# RD122PU1 GENERALMUSIC S.p.A. ITALY

CKD G.RICCI DATE: 22/06/2004 ALL RIGHTS ARE RESERVED, NO COPIES

APP. N.ZAVATTA REV: A

REAR IN/OUT BOARD OR REPRODUCE THIS DOCUMENT WITHOUT
WRITTEN CONSENT BY GENERALMUSIC.

1 2 3 4 5 6 7 8

14
 SKK081053 * DA204K 0.1A 20V SOT346 Smd Dual Switch. Diode (K)
Spare Part List SKK081052 * DAN202K 0.1A 80V SOT346 Smd Dual Switch.Diode (N)
Legend SKK075001 * 2x500KC Vert Rotary Potentiometer
EU = Europe Version 230Vac SKK074008 * 2x10KJQ Vert Rotary Potentiometer
US = United States Version 115Vac SKK074011 * 2x50KW Vert Rotary Potentiometer
Code Description SKK074007 * 2x50KB Vert Rotary Potentiometer
SKK074006 * 50KW Vert Rotary Potentiometer
Accessories SKK074005 * 50KB Vert Rotary Potentiometer
SKK887001 45X42X9Cm LEM Bag SKK073001 * 10KD 60mm Vertical Slim Slider Pot. Shaft H=15mm
SKK667000 Left Rack Bracket SKK073002 * 2x10KD 60mm Vertical Slim Slider Pot. Shaft H=15mm
SKK667001 Right Rack Bracket 106002 * NE555 SOIC Timer
277408 Owner’s Manual (English/Italian) 103014 * 74HC109D SOIC Dual J-/K F-F
130297 Mains Cable 10A (EU) 103000 * 74HC14D Soic Hex Inverter Schmitt Trigger
130283 Mains Cable 10A (US) 091001 * BC857B/C TO236 Smd Pnp Transistor (9BB/C-3F/G) (3H)
091000 * BC847B/C TO236 Smd Npn Transistor (8BB/C-1F/G) (1H)
Assembly SKK080706 * 3mm 60deg Diffused Green Led
SKK347029 Extension For Button SKK080707 * 3mm 60deg Diffused Red Led
SKK347028 Circular Gray Button SKK080708 * 3mm 60deg Diffused Yellow Led
SKK347027 Red/White Slider Knob
Digital Effect Chef-High Efx Board Assembly
SKK347026 Gray/White Slider Knob
SKK347025 11mm Red/Gray Rotary Knob SKK768281 Digital Effect Chef-High Efx Board (pcb#313123)
SKK347024 11mm Blue/Gray Rotary Knob SKK103068 * UDA1345TS SSOP28 20Bit Codec w/Volume
SKK347023 11mm Black/Gray Rotary Knob 550707 * AT27LV010A-70JC 1MBit OtpRom <RD82FX-1800h>
SKK347022 10mm Gray/White Rotary Knob SKK104076 ** AT27LV010A-70JC 1MBIT OTPROM SMD (SG00138)
SKK347017 Elliptical Gray Button 106008 * LM1117 Voltage Reg. 3,3V 0,8A TO252
SKK347016 14mm Gray/White Rotary Knob 105022 * CHEF Audio Effect Speaker Dsp.3,3v QFP44
SKK667008 Bottom Chassis 104075 * AS4LC256K16EO-60JC 256KX16 DRam (EDO) 3,3V
SKK667009 Rd122 Top Chassis 103000 * 74HC14D Soic Hex Inverter Schmitt Trigger
SKK667010 Rd122Fx Top Chassis 081000 * PMLL4148 Smd 100mA 75V Signal Diode
010704 * 16MHz Quartz Resonator
Mains Assembly
SKK235012 Transformer 230Vac 35W (EU)
SKK235013 Transformer 115Vac 35W (US)
SKK110009 Power Switch (Single Pole)
SKK110620 Mains Inlet with Fuse 5x20mm 10A max
110007 T250mA Fuse 5x20mm (EU)

Supply Board Assembly

SKK110010 Slim Power Switch (Single Pole)
SKK768190 RD122FX Supply Board Ass’y (Pcb# RD122PWR)
SKK768191 RD122 Supply Board Ass’y (Pcb# RD122PWR)
SKK080201 * 1N4756A 47V 1W 5% Zener Diode
SKK030002 * 220u 100V 20% Vert Electrolytic Capacitor
SKK030001 * 100u 100V 20% Vert Electrolytic Capacitor
100060 * 7815 +15V 1A Voltage Regulator
100059 * 7805 +5V 1A Voltage Regulator
100049 * 7915 -15V 1A Voltage Regulator
090559 * TIP122 TO220 Npn Darlington Transistor
080156 * 1N4002 1A 100V Rectifier Diode
030805 * 2200u 25V 20% Vert Electrolytic Capacitor
030413 * 47u 100V 20% Vert Electrolytic Capacitor

Rear In/Out Board Assembly

SKK768192 RD122FX Rear In/Out Board Ass’y (Pcb# RD122PU1)
SKK768193 RD122 Rear In/Out Board Ass’y (Pcb# RD122PU1)
SKK140006 * Vert Female Stereo JACK Socket
SKK140009 * Vert Male XLR Socket

Channels In/Out Board Assembly

SKK768194 RD122/122FX Channels In/Out Board Ass’y (Pcb# RD122PU2)
SKK140006 * Vert Female Stereo JACK Socket
SKK140008 * Quad Vertical Female RCA Socket
SKK140007 * Vert Female XLR Socket
SKK110007 * 2 Pole Vert Latching Push Switch
SKK106015 * NJM4580M DMP8 Smd Dual Low Noise Op. Amp.
SKK100001 * BA15218N SIP8 900mW Dual Op Amp
091001 * BC857B/C TO236 Smd Pnp Transistor (9BB/C-3F/G) (3H)
091000 * BC847B/C TO236 Smd Npn Transistor (8BB/C-1F/G) (1H)
SKK090008 * 2SA1316GR TO92 Pnp Low Noise Transistor
SKK081055 * BAS316 0.25A 75V SOD323 High Speed Rect.Diode
SKK075000 * 10KC Vert Rotary Potentiometer
042585 * 6K81 1/4W 1% Metalized Film Resistor
Note:
Main Board Assembly - All dimensions are in mm unless otherwise specified.
SKK768195 RD122FX Main Board Ass’y (Pcb# RD122MN1) - Each spare part is single quantity unless otherwise specified.
SKK768196 RD122 Main Board Ass’y (Pcb# RD122MN1) - Asterisk prefix explanation:
SKK110300 * Relay 5V / 2 Switch 1A 120Vac Omitted = First level spare part.
SKK110008 * 4 Pole Vert Latching Push Switch One asterisk = Second level, part of previous listed first level part.
SKK110007 * 2 Pole Vert Latching Push Switch Two asterisk = Third level, part of previous listed second level part.
SKK110006 * 2 Pole Vert Momentary Push Switch Three asterisk = ............
SKK110005 * Hex Binary Encoder - Any request for not above mentioned part must encompass specific description inclu-
SKK106015 * NJM4580M DMP8 Smd Dual Low Noise Op. Amp. ding:
SKK106010 * LM339 SOIC Quad Voltage Comparator 1) Model name,
SKK106006 * BA10393F SOIC Dual Voltage Comparator 2) Section name,
SKK091105 * MMBFJ112 SOT-23 N-Channel JFet (6R) 3) Module code,
SKK081055 * BAS316 0.25A 75V SOD323 Smd High Speed Diode (A6) 4) Reference name,
SKK081054 * RB400D 0.5A 40V SOT346 Smd Schottky Diode (D3A) 5) Quantity number.

15
16