Untitled

info_mart
TM 5-4310-393-24P
TECHNICAL MANUAL
UNIT, DIRECT SUPPORT AND GENERAL SUPPORT

MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST
FOR
COMPRESSOR UNIT, RECIPROCATING
5.0 CFM, MODEL CAPITANO-PD
(NSN 4310-01-107-8006)
DISTRIBUTION STATEMENT A: Approved for public release, distribution is unlimited.
HEADQUARTERS DEPARTMENT OF THE ARMY
MARCH 1999
info_mart
TM 5-4310-393-24P
TECHNICAL MANUAL HEADQUARTERS

No. 5-4310-393-24P DEPARTMENT OF THE ARMY
WASHINGTON D.C., 15 MARCH 1999
TECHNICAL MANUAL
REPAIR PARTS AND SPECIAL TOOLS LIST
Operator, Unit, Direct Support and General Support
FOR
COMPRESSOR UNIT, RECIPROCATING

5.0 CFM, MODEL CAPITANO-PD
(NSN 4310-01-107-8006)
REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS
You can help improve this manual. If you find any mistakes or if you know of a way to improve these
procedures, please let us know. Mail your letter or DA Form 2028 (Recommended Changes to
Publications and Blank Forms), or DA Form 2028-2 located in the back of this manual directly to:
Director, Armament and Chemical Acquisition and Logistic Activity (ACALA), ATTN: AMSTA-AC-NML,
Rock Island, IL 61299-7630. (E-mail: [email protected]). A reply will be furnished directly to
you. Instructions for sending an electronic 2028 may be found at the back of this manual immediately
preceding the hard copy 2028.
APPROVED FOR PUBLIC RELEASE; DISTRIBUTION IS UNLIMITED.
TABLE OF CONTENTS
PAGE FIGURE
Section 1. INTRODUCTION 1
Section 2. REPAIR PARTS LIST 8
Group 00 Frame and Hardware Assembly 1-1 1
Group 01 Reciprocating Compressor 2-1 2

Intake Filter Assembly 3-1 3
Cooling System 4-1 4
Oil Lubricating System 5-1 5
1st Stage Valve Head Assembly 6-1 6
2nd Stage Valve Head Assembly 7-1 7
3rd Stage Valve Head Assembly 8-1 8
2nd Stage Intermediate Filter 9-1 9
Pistons and Cylinders 10-1 10
Crankcase Assembly 11-1 11
Group 02 Diesel Engine, ENG-0040 12-1 12

Oil Bath Air Cleaner 13-1 13
Exhaust Muffler Assembly 14-1 14
i
info_mart
TM 5-4310-393-24P
TABLE OF CONTENTS - continued
PAGE FIGURE
Axial Fan Impeller/Flywheel. 15-1 15
Cowling Assembly 16-1 16
Fuel Injector. 17-1 17
Fuel Injection Pump 18-1 18
Hand Cranking Assembly 19-1 19
Cylinder Head. 20-1 20
Push-rods and Camfollowers Assembly 21-1 21
Timing Gears and Cover 22-1 22
Connecting Rod, Piston and Cylinder 23-1 23
Throttle Control 24-1 24
Impeller Guards 25-1 25
Crankshaft 26-1 26
Crankcase 27-1 27
Group 03 Purification System

Pressure Maintaining Valve 28-1 28
Purifier Chamber 29-1 29
Final Separator 30-1 30
Group 04 Instruments and Control Panel Assembly 31-1 31
Group 05 Diesel Fuel Tank Assembly 32-1 32
Group 06 Charging Whip Assembly 33-1 33
Group 07 Intake Hose Assembly 34-1 34
Section 3 SPECIAL TOOLS LIST 35-1 35
Section 4 CROSS REFERENCE INDEX I-1

National Stock Number Index I-1
National Stock Number and Part Number Index I-3
Figure and Item Number to Part Number Cross Reference I-14
ii
info_mart
TM 5-4310-393-24P
ORGANIZATIONAL AND INTERMEDIATE SUPPORT

MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS UST
SECTION 1 INTRODUCTION
1. SCOPE. This REPAIR PARTS AND SPECIAL TOOLS LIST (RPSTL) lists and authorizes spares and repair
parts; special tools; special test, measurement, and diagnostic equipment (TMDE); and other special support equipment
required for performance of operator, unit, direct support, and general support maintenance of the Reciprocating
Compressor Unit. It authorizes the requisitioning, issue, and disposition of spares, repair parts and special tools as
indicated by the source, maintenance and recoverability (SMR) codes.
2. GENERAL. In addition to this section, Introduction, this Repair Parts and Special Tools List is divided into the
following sections:
a. Section 1. Repair Parts List. A list of spares and repair parts authorized by this RPSTL for use in the
performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts.
Parts Lists are composed of functional groups in ascending alphanumeric sequence, with the parts in each group listed in
ascending figure and item number sequence. Repair parts for repairable special tools are listed in Section 3. Items listed
are shown on the associated illustration(s)/figure(s). There is no authorized DOD depot facility for the CAPITANO-PD,
Reciprocating Compressor Unit. After proper authorization all items whose SM&R codes indicates Depot level repair or
replacement will be returned to the manufacturer or other commercial facility for repair/overhaul.
b. Section 3 Special Tools List. A list of special tools, special TMDE, and other special support equipment
authorized by this RPSTL (as indicated by Basis of Issue (BOI) information in DESCRIPTION AND USABLE ON CODE
column) for the performance of maintenance.
c. Section 4. Cross-reference Index. A list, in National Item Identification Number (NIIN) sequence, of all
National Stock numbered items appearing in the listing, followed by a list in alphanumeric sequence of all part numbers
appearing in the listings. National stock numbers and part numbers are cross referenced to each illustration figure and
item number appearance. The figure and item number index lists figure and item number in alphanumeric sequence and
cross references NSN, CAGEC and part number.
3. EXPLANATION OF COLUMNS (SECTIONS II AND Ill).
a. ITEM NO. (Column (1)). Indicates the number used to identify items called out in the illustration.
b. SMR Code (Column (2)). The Source, Maintenance, and Recoverability (SMR) code is a 5-position code
containing supply/requisitioning information, maintenance category authorization criteria, and disposition instruction, as
shown in the following:
Source Maintenance Recoverability
Code Code Code
XX XX XX
Character 1&2 Character 3 Character 4 Character 5

How you get an item. Who can install, Who can do Who determines
replace or use a complete repair* disposition action
on the item on the item on an unservice-
able item.
*Complete Repair: Maintenance capacity, capability, and authority to perform all corrective maintenance tasks of the
'Repair' function in a use/user environment in order to restore serviceability to a failed item.
1
info_mart
TM 5-4310-393-24P
(1) Source Code. The source code tells you how to get an item needed for maintenance, repair, or overhaul of an
end item/ equipment. Explanations of source codes follows:
Code Explanation
PA Stocked items; use the applicable NSN to request/requisition
items with these source codes. They are authorized to the
category indicated by the code entered in the 3rd position of the
SMR code.
PB
PC** ** NOTE: Items coded PC are subject to deterioration
PD
PE
PF
PG
KD Items with "K" codes are not to be requested/requisitioned
individually. They are part of a kit which is authorized to the
maintenance category indicated in the 3rd position of the SMR
code. The complete kit must be requisitioned and applied.
KF
KB
MO Made at org/AVUM Items with "M" codes are not to be requested/requisitioned
Level individually They must be made from bulk material which is
identified by the number in the DESCRIPTION and USABLE
ON CODE (UOC) column with and listed in the Bulk Material
group on the repair parts list in the RPSTL. If the item is
authorized to you by the 3rd position code of the SMR code, but
the source code indicates it is made at a higher level, order the
item from the higher level of maintenance.
MF Made at DS/AVUM
Level
MH Made at GS Level
ML Made at Specialized
Repair Activity (SRA)
MD Made at Depot
AO Assembled by Items with "A" codes are not to be requested/requisitioned
org/AVUM Level individually. The parts that make up the assembled item must
be requisitioned or fabricated and assembled at the level of
maintenance indicated by the source code. If the 3rd position
code of the SMR code authorizes you to replace the item, but
the source code indicates the items are assembled at a higher
level, order the item from the higher level of maintenance.
AF Assembled by
DS/AVIM Level
AH Assembled by GS
Category
AL Assembled by SRA
AD Assembled by Depot
XA Do not requisition "XA" -coded item. Order its next higher
assembly. (Also, refer to the NOTE below).
2
info_mart
TM 5-4310-393-24P
XB If an "XB" item is not available from salvage, order it using the

CAGEC and part number given.
XC Installation drawing, diagram, instruction sheet, field service
drawing, that is identified by Reciprocating Compressor Unit's
manufacturers part number
XD Item is not stocked. Order an "XD" -coded item through normal
supply channels using the CAGEC and part number given if no
NSN is available.
NOTE
Cannibalization or controlled exchange, when authorized, may be used as a source

of supply for items with the above source codes, except for those source coded
"XA" or those aircraft support items restricted by requirements of AR 750-1.
(2) Maintenance Code. Maintenance codes tells you the level(s) of maintenance authorized to USE and REPAIR
support items. The maintenance codes are entered in the third and fourth positions of the SMR code as follows:
(a) The maintenance code entered in the third position tells you the lowest maintenance level authorized to
remove, replace, and use an item. The maintenance code entered in the third position will indicate authorization to one of
the following levels of maintenance.
Code Application/Explanation
C - Crew or operator maintenance done within organizational or aviation unit maintenance.

O - Organizational or aviation unit category can remove, replace, and use the item.
F - Direct support or aviation intermediate level can remove, replace, and use the item.
H - General support level can remove, replace, and use the item.
L - Specialized repair activity can remove, replace, and use the item.
D - Depot level can remove, replace, and use the item.
(b) The maintenance code entered in the fourth position tells whether or not the item is to be repaired and
identifies the lowest maintenance level with the capability to do complete repair (i.e., perform all authorized repair
functions). NOTE: Some limited repair may be done on the item at a lower level of maintenance, if authorized by the
Maintenance Allocation Chart (MAC) and SMR codes. This position will contain one of the following maintenance codes.
O - Organizational or (aviation unit) is the lowest level that can do complete repair of the item.
F - Direct support or aviation intermediate is the lowest level that can do complete repair of the item.
H - General Support is the lowest level that can do complete repair of the item.
L - Specialized repair activity is the lowest level that can do complete repair of the item.
D - Depot is the lowest level that can do complete repair of the item.
3
info_mart
TM 5-4310-393-24P
Z - Nonreparable. No repair is authorized.
B - No repair is authorized. (No parts or special tools are authorized for the maintenance of a "B" coded item).
However, adjusting, lubricating, etc., at the user level may recondition the item.
(3) Recoverability Code. Recoverability codes are assigned to items to indicate the disposition action on
unserviceable items. The recoverability code is entered in the fifth position of the SMR Code as follows: Recoverability
Z Nonreparable item. When unserviceable, condemn and dispose of the item at the level of maintenance shown in
third position of SMR Code.
O Reparable item. When not economically reparable, condemn and dispose of the item at organizational or aviation
unit level.
F Reparable item. When uneconomical to repair, condemn and dispose of the item at the direct support or aviation
intermediate level.
H Reparable item. When uneconomical to repair, condemn and dispose of the item at the general support level.
D Reparable item. When beyond lower level repair capability, return to depot.
Condemnation and disposal of item not authorized below depot level.
L Reparable item. Condemnation and disposal not authorized below specialized repair activity (SRA).
A Item requires special handling or condemnation procedures because of specific reasons (e.g., precious metal
content, high dollar value, critical material, or hazardous material). Refer to appropriate manuals/directives for
specific instructions.
c. CAGEC (Column (3)). The Commercial and Government Entity Code (CAGEC) is a 5 digit numeric code which is
used to identify the manufacturer, distributor, or Government agency, etc., that supplies the item.
d. PART NUMBER (Column (4)). Indicates the primary number used by the manufacturer, (individual, company,
firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its
engineering drawings, specifications standards, and inspection requirements to identify an item or range of items.
NOTE
When you use an NSN to requisition an item, the item you receive may have a
different part number from the part ordered.
e. DESCRIPTION AND USABLE ON CODE (UOC) (Column (5)). This column includes the following information:
(1) The Federal item name and, when required, a minimum description to identify the item.
4
info_mart
TM 5-4310-393-24P
(2) The physical security classification of the item is indicated by the parenthetical entry, e.g., Phy Sec Cl
Confidential, Phy Sec C1 (S) -Secret, Phy Sec Cl (T) Top Secret.
(3) Items that are included in kits and sets are listed below the name of the kit or set.
(4) Spare/repair parts that make up an assembled item are listed immediately following the assembled item line
entry.
(5) Part numbers for bulk materials are referenced in this column in the line item entry for the item to be
manufactured/Fabricated.
(6) When the item is not used with all serial numbers of the same model, the effective serial number are shown
on the last line(s) of the description (before UOC).
(7) The usable on code, when applicable (see paragraph 5, Special Information).
(8) In the Special Tools List section, the basis of issue (BOI) appears as the last line(s) in the entry for each
special tool, special TMDE, and other special support equipment. When density of equipment supported exceeds density
spread indicated in the basis of issue, the total authorization is increased proportionately.
(9) The statement "END OF FIGURE" appears just below the repair part, indicates that the item is a repair part
of the next higher assembly.
f. QTY (Column (6)). The QTY (quantity per figure column) indicates the quantity of the item used in the breakout
shown on the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly. A "V"
appearing in this column in lieu of a quantity indicates that the quantity is variable and may vary from application to
application.
4. EXPLANATION OF COLUMNS (SECTION 4).
a. NATIONAL STOCK NUMBER (NSN) INDEX.
(1) STOCK NUMBER column. This column lists the NSN by National item identification number (NIIN)
sequence. The NIIN consists of the last nine digits of the NSN, i.e. For the NSN 5305-02-574-1467 the NIIN is 02-574-
1467 When using this column to locate an item, ignore the first 4 digits of the NSN. However, the complete NSN should
be used when ordering items by stock number.
(2) FIG. column. This column lists the number of the figure where the item is identified/located. The figures
are in numerical order in Section 2 and Section 3.
(3) ITEM column. The item number identifies the item associated with the figure listed in the adjacent FIG.
column. This item is also identified by the NSN listed on the same line.
b. PART NUMBER INDEX. Part numbers in this index are listed by part number in ascending alphanumeric
sequence (i.e., vertical arrangement of letter and number combination which places the first letter or digit of each group in
order A through Z, followed by the numbers O through ( and each following letter or digit in like order.
(1) CAGEC column. The Commercial and Government Entity Code (CAGEC) is a 5 digit numeric code used to
identify the manufacturer, distributor, or Government agency, etc., that supplies the item.
5
info_mart
TM 5-4310-393-24P
(2) PART NUMBER column. Indicates the primary number used by the manufacturer (individual, firm,
corporation or Government activity), which controls the design and characteristics of the item by means of its engineering
drawings, specifications standards, and inspection requirements to identify an item or range of items.
(3) STOCK NUMBERS column. This column lists the NSN for the associated part number and manufacturer
identified in the PART NUMBER and CAGEC columns to the left.
(4) FIG. column. This column lists the number of the figure where the item is identified/located in Sections II
and III.
(5) ITEM column. The item number is that number assigned to the item as it appears in the figure referenced
in adjacent figure number column.
c. FIGURE AND ITEM NUMBER INDEX.
(1) FIG. column. This column lists the number of the figure where the item is identified/located in Section 2
and 3.
(2) ITEM column. The item number is that number assigned to the item as it appears in the figure referenced
in the adjacent figure number column.
(3) STOCK NUMBER column. This column lists the NSN for the item.
(4) CAGEC column. The Commercial and Government Entity Code (CAGEC) is a 5 digit numeric code used to
identify the manufacturer, distributor, or Government agency, etc., that supplies the item.
(5) PART NUMBER column. Indicates the primary number used by the manufacturer (individual, firm,
corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering
drawings, specifications standards, and inspection requirements to identify an item or range of items.
5. SPECIAL INFORMATION.
a. USABLE ON CODE. The usable on code appears in the lower corner of the Description column heading. Usable
on codes are shown as "UOC ........ "in the Description Column (justified left) on the last line applicable item
description/nomenclature. Uncoded items are applicable to all models.
b. ASSOCIATED PUBLICATIONS. The publications listed below pertain to the 20 CFM Diving Air Compressor and
its components.
Publication Short Title

TM 5-4310-393-14 Operator, Unit, Direct Support, General Support and Maintenance
Manual for Compressor Unit, Reciprocating 5.0 CFM,
Model CAPITANO-PD
6. HOW TO LOCATE REPAIR PARTS.
a. When National Stock Number or Part Number is NOT Known.
6
info_mart
TM 5-4310-393-24P
(1) First. Using the table of contents, determine the assembly group or subassembly group to which the item
belongs. This is necessary since figures are prepared for assembly groups and subassembly groups, and listings are
divided into the same groups.
(2) Second. Find the figure covering the assembly group or subassembly group to which the item belongs.
(3) Third. Identify the item on the figure and note the item number.
(4) Fourth. Refer to the Repair Parts List for the figure to find the part number for the item number noted on the
figure.
(5) Fifth. Refer to the Part Number Index to find the NSN, if assigned.
b. When National Stock Number or Part Number IS Known.
(1) First. Using the Index of National Stock Numbers and Part Numbers, find the pertinent National Stock
Number or Part Number. The NSN index is in National Item Identification Number (NIIN) sequence (see c-4a.(1)). The
part numbers in the Part Number index are listed in ascending alphanumeric sequence (see paragraph c-4.b). Both
indexes cross-reference you to the illustration figure and item number of the item you are looking for.
(2) Second. After finding the figure and item number, verify that the item is the one you are looking for, then
locate the item number in the repair parts list for the figure.
7. ABBREVIATIONS. Abbreviations used in this manual are listed in MIL-STD-12.
7
info_mart
TM 5-4310-393-24P
SECTION 2 REPAIR PARTS LIST
The Repair Parts List is a list of spares and repair parts authorized by this RPSTL for use in the performance of
maintenance. The list also includes parts, which must be removed for replacement of the authorized parts. Parts Lists
are composed of functional groups in ascending alphanumeric sequence, with the parts in each group listed in ascending
figure and item number sequence Repair parts for repairable special tools are listed in Section 3. Items listed are shown
on the associated illustration(s)/figure(s).
There is no authorized DOD depot facility for the CAPITANO-PD, Reciprocating Compressor Unit. After proper
authorization all items whose SM&R codes indicates Depot level repair or replacement will be returned to the
manufacturer or other commercial facility for repair/overhaul.
8
info_mart
TM 5-4310-393-24P
FIGURE 1. Frame ad Hardware Assembly (Sheet 1 of 3 )

info_mart
TM 5-4310-393-24P
Figure 1. Frame and Hardware Assembly (Sheet 2 of 3)

info_mart
TM 5-4310-393-24P
Figure 1. Frame and Hardware Assembly (Sheet 3 of 3)

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
NO CODE CAGEC NUMBER DESCRIPTION AND USABLE ON CODES (UOC) QTY
GROUP 00 FRAME AND HARDWARE ASSEMBLY
FIGURE 1 FRAME AND HARDWARE ASSEMBLY
1 XDFFZ 573281 8782-17 • FRAME ASSEMBLY .......................................................... 1

2 PAOZZ 57328 NUT-0124 •• NUT, SELF-LOCKING, HEX .............................................. 24
3 XDOZZ 57328 18782-AC •• LATCH, ADJUSTABLE DRAW .......................................... 4
4 XDOZZ 57328 SCR-0127 •• SCREW, MACHINE ........................................................... 24
5 XDFFF 57328 FRM-0200 •• FRAME, ENGINE SIDE ...................................................... 1
6 XDFFF 57328 FRM-0199 •• FRAME, COMPRESSOR SIDE .......................................... 1
7 XDOZZ 57328 18782-AH •• CAP, PROTECTIVE, DUST AND MOISTURE ..................... 4
8 XDFZZ 57328 RIV-0001 •• RIVET, BLIND ................................................................... 60
9 XDFZZ 57328 18782-BE •• WASHER, FENDER .......................................................... 48
10 XDFZZ 57328 LBL-0509 •• LABEL "DIESEL FUEL ONLY" ........................................... 1
11 XDFZZ 57328 LBL-0663 •• LABEL "HOURMETER ON" ............................................... 1
12 XDOZZ 57328 NUT-0133 •• NUT, CAGE....................................................................... 17
13 XDOZZ 57328 SCR-0011 •• SCREW, CAP, HEX HEAD ................................................ 17
14 XDOZZ 57328 WAS-0017 •• WASHER, FLAT................................................................ 23
15 XDOZZ 57328 WAS-0003 •• WASHER. LOCK .............................................................. 17
16 XDOZZ 57328 GRD-0256 •• GUARD, AIR COMPRESSOR ........................................... 1
17 XDOZZ 57328 SUP-0157 •• BRACKET, MOUNTING ..................................................... 1
18 XDFZZ 57328 LBL-0513 •• LABEL "CAUTION HEARING" ........................................... 4
19 XDFZZ 57328 LBL-0530 •• LABEL "SHIPPING DATA, ENGINE" .................................. 1
20 XDFZZ 57328 LBL-0515 •• LABEL "DATA PLATE" ...................................................... 2
21 XDFZZ 57328 LBL-0514 •• LABEL "MAINTENANCE" .................................................. 1
22 XDFZZ 57328 LBL-0517 •• LABEL "PNEUMATIC DIAGRAM" ...................................... 1
23 XDFZZ 57328 SCR-0115SS •• SCREW, CAP, HEX HEAD ................................................ 4
24 XDFZZ 57328 SCR-0116SS •• SCREW, CAP, HEX HEAD ................................................ 4
25 PAFZZ 57328 WAS 0031 •• WASHER, FLAT ............................................................... 14
26 PAFZZ 57328 WAS-0030 •• WASHER, LOCK ............................................................... 14
27 PBFZZ 57328 N03292 •• MOUNT, RESILIENT ......................................................... 4
28 XDFZZ 57328 BAS-0085 •• BRACKET, ENGINE MOUNT ............................................ 1
29 XDFZZ 57328 BAS-0068 •• BRACKET, ENGINE MOUNT ............................................ 1
30 PAOZZ 57328 NUT-0076 •• NUT, PLAIN, HEX ............................................................. 6
31 PBOZZ 57328 N01547 •• MOUNT, RESILIENT ......................................................... 6
32 XDOZZ 57328 SCR-0211 •• SCREW, TAPPING THREAD FORMING............................. 6
33 MOOZZ 57328 EDG-0001 •• TRIM, DECORATIVE ........................................................ 4
34 XDOZZ 57328 GRD-0196 •• GUARD, AIR COMPRESSOR ........................................... 1
35 XDFZZ 57328 LBL-0516 •• LABEL "OPERATING INSTRUCTIONS" ............................. 1
36 XDFZZ 57328 LBL-0511 •• LABEL "DANGER, THE CARTRIDGE ................................. 1
37 XDFZZ 57328 LBL-0508 •• LABEL "SERVICE OUTLET" ............................................. 1
38 XDFZZ 57328 LBL-0512 •• LABEL "WARNING, LUBRICANTS" ................................... 1
39 XDOZZ 57328 SCR-0066 •• SCREW, TAPPING THREAD FORMING............................. 5
40 XDOZZ 57328 18782-AW •• PLASTIC TUBE CLAMP .................................................... 5
41 XDFZZ 57328 LBL-0510 •• LABEL "SHIPPING DATA, COMPRESSOR" ....................... 1
END OF FIGURE
1-1
info_mart
TM 5-4310-393-24P
Figure 2. Reciprocating Compressor

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
GROUP 01 RECIPROCATING COMPRESSOR
FIGURE 2 RECIPROCATING COMPRESSOR
1 PDODD 57328 KC-FH US GOV'T • COMPRESSOR, RECIPROCATING ..................................... 1

2 XDOZZ 57328 NUT-0079 • NUT, SELF-LOCKING, HEX ............................... .................. 4
3 XDOZZ 57328 WAS-0040 • WASHER, FLAT ........................................ ........................... 8
4 XDOZZ 57328 SCR-0080 • SCREW, CAP, HEX HEAD ............................... .................... 24
END OF FIGURE
2-1
info_mart
TM 5-4310-393-24P
Figure 3. Intake Filter Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 3 INTAKE FILTER ASSEMBLY
1 XDOZZ 57328 013758 • AIR CLEANER, INTAKE .................................................... 1

2 XAOZZ 57328 012771 •• COVER, ACCESS ............................................................. 1
3 PAOZZ 57328 010528 •• SPRING, HELICAL, COMPRESSION ................................. 1
4 XDOZZ 57328 N04451 •• PACKING, PREFORMED................................................... 1
5 PAOZZ 57328 N00070 •• FILTER ELEMENT, INTAKE AIR CLEANER........................ 1
6 PAOZZ 57328 013757 •• PACKING, PREFORMED................................................... 1
7 XDOZZ 57328 N03374 •• CLAMP HOSE................................................................... 1
8 XAOZZ 57328 012770 •• HOUSING, AIR CLEANER................................................. 1
END OF FIGURE
3-1
info_mart
TM 5-4310-393-24P
Figure 4. Cooling System (Sheet 1 of 3)

info_mart
TM 5-4310-393-24P

info_mart
TM 5-4310-393-24P

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 4 COOLING SYSTEM
1 XDOZZ 57328 014624 • COOLER, FLUID, INDUSTRIAL ....................................... 1

2 XDOZZ 57328 NUT-0118 •• NUT, SELF-LOCKING, HEX ............................................ 9
3 XDOZZ 57328 WAS-0024 •• WASHER, FLAT ............................................................. 21
4 XDOZZ 57328 SCR-0051 •• SCREW, CAP, HEX HEAD .............................................. 8
5 XDOZZ 57328 013662 •• HANGER, PIPE .............................................................. 4
6 XDOZZ 57328 013663 •• BRACKET, MOUNTING .................................................. 4
7 XDOZZ 57328 014605 •• SPACER, SLEEVE ......................................................... 1
8 XDOZZ 57328 UNN-0050SS •• COUPLING, TUBE .......................................................... 1
9 XDOZZ 57328 069957 •• TUBE ASSEMBLY, METAL ............................................. 1
11 XDOZZ 57328 014564 •• HANGER, PIPE .............................................................. 2
12 XDOZZ 57328 SCR-0110 •• SCREW, CAP, HEX HEAD .............................................. 3
13 PAOZZ 57328 BET-0021 • ELT, V ............................................................................ 1
14 XDOZZ 57328 SCR-0159 • SCREW, CAP, SOCKET HEAD ....................................... 4
15 XDOZZ 57328 WAS-0001 • WASHER, SPLIT ............................................................ 5
16 XDOZZ 57328 012754 • IMPELLER, FAN, AXIAL/PULLEY, GROOVE ................... 1
17 XDDZZL 57328 N01437 • SCREW, CAP, SOCKET HEAD ....................................... 1
18 XDDZZ 57328 013666 • HUB, FAN CLUTCH ........................................................ 4
19 XDOZZ 57328 SCR-0192 • SCREW, CAP, HEX HEAD .............................................. 1
20 XDOZZ 57328 014139 • HANGER, PIPE .............................................................. 2
21 XDOZZ 57328 014370 • CLAMP, LOOP ............................................................... 1
23 XDOZZ 57328 UNN-0020SS • COUPLING, TUBE .......................................................... 1
END OF FIGURE
4-1
info_mart
TM 5-4310-393-24P
Figure 5. Oil Lubricating System

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 5 OIL LUBRICATING SYSTEM
1 PAOZZ 57328 TIE-0008 • STRAP, TIEDOWN, ELECTRICAL ................................... 1

2 PAOZZ 57328 TUB-0339 • GUARD, WEAR .............................................................. 1
3 PAOZZ 57328 069966 • TUBE ASSEMBLY, METAL ............................................. 1
5 XDOZZ 57328 WAS-0021 • WASHER, FLAT.............................................................. 3
6 PAOZZ 57328 N00083 • PUMP, RECIPROCATING ............................................... 1
7 PAOZZ 57328 002010 • GASKET ........................................................................ 1
10 XDOZZ 57328 N03407 • SCREW, CAP, SOCKET HEAD ....................................... 2
11 XDOZZ 57328 058138 • VALVE, REGULATING, FLUID PRESSURE ..................... 1
END OF FIGURE
5-1
info_mart
TM 5-4310-393-24P
Figure 6. 1st Stage Valve Head Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 6 1ST STAGE VALVE HEAD ASSEMBLY
1 XDOZZ 57328 CON-0266SS • COUPLING, TUBE .......................................................... 1

2 XDOZZ 57328 N03737 • COUPLING, TUBE .......................................................... 1
3 XDOZZ 57328 069951 • HEAD, VALVE ................................................................ 1
4 PAOZZ 57328 014583 •• VALVE, DISCHARGE ..................................................... 1
5 XDOZZ 57328 SCR-0180 •• SCREW, CAP, SOCKET HEAD........................................ 3
6 XDOZZ 57328 014907 •• HEAD, VALVE ................................................................ 1
7 PAOZZ 57328 009884 •• VALVE, INLET ................................................................ 1
8 PAOZZ 57328 N02169 •• PACKING, PREFORMED ................................................ 1
END OF FIGURE
6-1
info_mart
TM 5-4310-393-24P
Figure 7. 2nd Stage Valve Head Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 7 2ND STAGE VALVE HEAD ASSEMBLY

2 XDOZZ 57328 010670 • VALVE, SAFETY RELIEF ................................................ 1
3 PAOZZ 57328 008264 • GASKET ........................................................................ 1
5 PAOZZ 57328 N01316 • GASKET ........................................................................ 1
6 XDOZZ 57328 069955 • HEAD, VALVE ................................................................ 1
8 XDOZZ 57328 SCR-0180 •• SCREW, CAP, SOCKET HEAD........................................ 6
9 XDOZZ 57328 014123 •• HEAD, VALVE ................................................................ 1
10 PAOZZ 57328 012841 •• VALVE, INLET................................................................. 1
END OF FIGURE
7-1
info_mart
TM 5-4310-393-24P
Figure 8. 3rd Stage Valve Head Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 8 3RD STAGE VALVE HEAD ASSEMBLY

3 PAOZZ 57328 N01316 • GASKET ........................................................................ 1
4 XDOZZ 57328 069954 • HEAD, VALVE ................................................................ 1
5 XDOZZ 57328 N03623 •• NUT, CAP, PLAIN ........................................................... 1
6 PAOZZ 57328 N03625 •• GASKET ........................................................................ 1
7 XDOZZ 57328 071065 •• SET SCREW................................................................... 1
8 XDOZZ 57328 NO1282 •• SCREW, CAP, SOCKET HEAD ....................................... 6
9 XDOZZ 57328 014118 •• COVER, ACCESS .......................................................... 1
10 XDOZZ 57328 014117 •• HEAD, VALVE ................................................................ 1
11 PAOZZ 57328 N02789 •• PACKING, PREFORMED................................................. 1
13 PAOZZ 57328 007790 •• VALVE, INLET ................................................................ 1
END OF FIGURE
8-1
info_mart
TM 5-4310-393-24P
Figure 9. 2nd Stage Intermediate Filter

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 9 2ND STAGE INTERMEDIATE FILTER

3 XDOZZ 57328 PLU-0028 • PLUG, PIPE ................................................................... 1
4 PAOZZ 57328 N04051 • GASKET ......................................................................... 1
XDOZZ 57328 NUT-0055SS • NUT, TUBE COUPLING .................................................. 1
7 XDOZZ 57328 N15843 • PLUG, TUBE FITTING, THREADED ................................ 1
8 XDOZZ 57328 011656 • VALVE, SAFETY RELIEF ................................................ 1
9 PAOZZ 57328 004479 • GASKET ........................................................................ 1
10 XDOZZ 57328 011430 • MANUAL DRAIN VALVE ................................................. 1
11 XDOZZ 57328 NUT-0062 • NUT, PLAIN, HEX ........................................................... 2
12 XDOZZ 57328 N02862 • WASHER, FLAT ............................................................. 2
13 XDOZZ 57328 014368 • BRACKET, FILTER, MOUNTING ..................................... 1
14 XDOZZ 57328 WAS-0021 • WASHER, FLAT ............................................................. 2
15 XDOZZ 57328 SCR-0025 • SCREW, CAP, HEX HEAD .............................................. 2
16 XDOZZ 57328 067612 • FILTER, FLUID ............................................................... 1
17 XDOZZ 57328 013937 •• COLLAR, THREADED .................................................... 1
18 XDOZZ 57328 013930 •• HEAD, FLUID FILTE R ..................................................... 1
19 XDOZZ 57328 012786 •• SCREW, CENTER .......................................................... 1
20 PAOZZ 57328 N02726 •• FILTER ELEMENT, FLUID .............................................. 1
21 XDOZZ 57328 012785 •• DEFLECTOR, DIRT & LIQUID ......................................... 1
22 XDOZZ 57328 012784 •• FILTERING DISK, FLUID ................................................ 1
24 XDOZZ 57328 014150 •• FILTER BODY, FLUID ..................................................... 1
25 XDOZZ 57328 055097 •• LABEL "IMPORTANT! DRAIN...”....................................... 1
END OF FIGURE
9-1
info_mart
TM 5-4310-393-24P
Figure 10. Pistons and Cylinders (Sheet 1 of 2)

info_mart
TM 5-4310-393-24P
Figure 10. Pistons and Cylinders (Sheet 2 of 2)

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 10 PISTON AND CYLINDERS
1 XDDZZ 57328 NUT-0119 • NUT, SELF-LOCKING, HEX............................................. 12

2 XDDZZ 57328 WAS-0021 • WASHER, FLAT ............................................................. 12
3 XDDDD 57328 006540 • CYLINDER, RECIPROCATING COMPRESSOR ............... 1
5 PADZZ 57328 001867 • GASKET ......................................................................... 1
6 PADZZ 57328 003110 • GASKET ......................................................................... 1
7 XDDZZ 57328 N00215 • STUD, PLAIN ................................................................. 8
8 XDDZZ 57328 069948 • PISTON, COMPRESSOR................................................. 1
9 PADZZ 57328 N03856 •• RING SET, PISTON ........................................................ 1
10 XDDZZ 57328 069949 •• PISTON, COMPRESSOR................................................. 1
11 PADZZ 57328 N04158 •• RING SET, PISTON ........................................................ 1
12 XDDDD 57328 065094 • BAFFLE, AIR FLOW, COMPRESSOR ............................. 1
14 XDDDD 57328 066934 • PISTON, COMPRESSOR................................................. 1
15 PADZZ 57328 N23755 •• PACKING, PREFORMED ................................................ 1
16 PADZZ 57328 N02320 •• PACKING, PREFORMED ................................................ 2
17 PADZZ 57328 N04064 • PACKING, PREFORMED................................................. 1
19 PADZZ 57328 001866 • GASKET ......................................................................... 1
20 XDDZZ 57328 N04065 • STUD, PLAIN ................................................................. 4
21 XDDDD 57328 069950 • PISTON, COMPRESSOR................................................. 1
END OF FIGURE
10-1
info_mart
TM 5-4310-393-24P
Figure 11. Crankcase Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 11 CRANKCASE ASSEMBLY
1 XDDZZ 57328 SCR-0025 • SCREW, CAP, HEX HEAD .............................................. 6

2 XDDZZ 57328 WAS-0021 • WASHER, FLAT ............................................................. 6
3 XDDZZ 57328 014998 • BRACKET, MOUNTING .................................................. 1
4 XDDZZ 57328 014878 • COVER, ACCESS .......................................................... 1
5 PADZZ 57328 N03705 • PACKING, PREFORMED ................................................ 1
6 XDDZZ 57328 SCR-0179 • SCREW, CAP, SOCKET HEAD ....................................... 3
7 XDDZZ 57328 058159 • BRACKET, MOUNTING .................................................. 1
8 XDOZZ 57328 N03333 • RIVET, BLIND ................................................................ 2
9 XDOZZ 57328 067275 • LABEL, "MADE IN GERMANY" ....................................... 1
10 PADZZ 57328 N03726 • PACKING, PREFORMED ................................................ 1
11 XDDZZ 57328 SCR-0065 • SCREW, CAP, HEX HEAD .............................................. 2
12 XDDZZ 57328 014888 • PLATE, RETAINING, SHAFT ........................................... 1
13 XDDZZ 57328 0033196 • CAM, CONTROL ............................................................ 1
14 XDDZZ 57328 014030 • CRANKSHAFT, COMPRESSOR ...................................... 1
15 XDDZZ 57328 N03703 • BEARING UNIT, ROLLER ............................................... 1
16 XDDZZ 57328 N03702 • BEARING UNIT, ROLLER ............................................... 1
17 XDDZZ 57328 N00220 • PACKING, PREFORMED ................................................ 1
18 XDOZZ 57328 014886 • GAUGE ROD-CAP, LIQUID LEVEL.................................. 1
19 PAOZZ 57328 N03521 • PACKING, PREFORMED ................................................ 1
21 XDOZZ 57328 N03026 • WASHER, SPRING TENSION ......................................... 2
22 XDOZZ 57328 014887 • FILLER NECK ................................................................ 1
23 PAOZZ 57328 012560 • GASKET ........................................................................ 1
24 MOOZZ 57328 N03736 • HOSE, NONMETALLIC ................................................... 8
26 PAOZZ 57328 014892 • BREATHER .................................................................... 1
27 PAOZZ 57328 N03207 •• BREATHER .................................................................... 1
29 PAOZZ 57328 N00293 •• GASKET ........................................................................ 1
30 XDOZZ 57328 N03707 • PLUG, PIPE ................................................................... 1
31 XDOZZ 57328 073270 • COUPLING, PIPE ........................................................... 1
32 XDDZZ 57328 014874 • HOUSING, AIR COMPRESSOR ...................................... 1
END OF FIGURE
11-1
info_mart
TM 5-4310-393-24P
Figure 12. Diesel Engine, ENG-0040

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
GROUP 02 DIESEL ENGINE, ENG-0040
FIGURE 12 DIESEL ENGINE, ENG-0040
1 XDFZZ 57328 18782-BJ • NUT, SELF-LOCKING, HEX............................................. 4

2 XDFZZ 57328 WAS-0016 • WASHER, FLAT ............................................................. 8
3 XDFZZ 57328 SCR-0004 • SCREW, CAP, HEX HEAD .............................................. 4
4 PDFFF 57328 ENG-0040 • ENGINE, DIESEL ............................................................ 1
END OF FIGURE
12-1
info_mart
TM 5-4310-393-24P
Figure 13. Oil Bath Air Cleaner

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 13 OIL BATH AIR CLEANER
1 XDOZZ 61080 500 230 00 • NUT, PLAIN, HEX............................................................ 2

2 XDOZZ 61080 502 085 00 • WASHER, LOCK ............................................................. 2
3 PAOZZ 61080 400 994 00 • AIR CLEANER, INTAKE .................................................. 1
4 XDOZZ 61080 400 995 00 • CAP, PROTECTIVE, DUST AND MOISTURE ................... 1
5 XDOZZ 61080 012 846 00 • SHIM SET (4 PIECES) .................................................... 1
6 XDOZZ 61080 500 372 00 • STUD, PLAIN ................................................................. 2
7 XDOZZ 61080 036 311 02 • LABEL, "MAINTENANCE" ............................................... 1
8 XDOZZ 61080 033 963 01 • LABEL, "ATTENTION" .................................................... 1
END OF FIGURE
13-1
info_mart
TM 5-4310-393-24P
Figure 14. Exhaust Muffler Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 14 EXHAUST MUFFLER ASSEMBLY
1 XDOZZ 61080 400 816 00 • NUT, PLAIN, HEX ........................................................... 1

2 XDOZZ 57328 MUF-0018 • MUFFLER, EXHAUST ..................................................... 1
3 XDOZZ 61080 012 861 00 • SHIM SET (5 PIECES) .................................................... 1
4 PAOZZ 61080 500 372 00 • STUD, PLAIN ................................................................. 2
5 XDOZZ 57328 18782-BH • SCREW, CAP, HEX HEAD .............................................. 1
6 XDOZZ 57328 WAS-0016 • WASHER, FLAT ............................................................. 1
7 XDOZZ 57328 NUT-0002 • NUT, PLAIN, HEX ........................................................... 2
8 XDOZZ 57328 CMP-0053 • CLAMP, HOSE ............................................................... 1
9 XDOZZ 57328 18782-AP • MUFFLER, EXHAUST ..................................................... 1
END OF FIGURE
14-1
info_mart
TM 5-4310-393-24P
Figure 15. Axial Fan Impeller/Flywheel

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 15 AXIAL FAN IMPELLER/FLYWHEEL
1 XDFZZ 57328 BUS-0011 • BUSHING, TAPERED ..................................................... 1

2 XDFZZ 57328 WAS-0033 •• WASHER, LOCK, SPLIT ................................................. 2
3 XDFZZ 57328 SCR-0011 •• SCREW, CAP, HEX HEAD .............................................. 2
4 XDFZZ 57328 SHE-0217 • PULLEY, GROOVE ......................................................... 1
5 XDFZZ 61080 500 538 00 • SCREW, CAP, SOCKET HEAD ....................................... 4
6 XDFZZ 61080 500 028 00 • WASHER, LOCK ............................................................. 4
7 PAFZZ 57328 N01386 • KEY, MACHINE ............................................................... 1
8 XDFZZ 57328 SHF-0023 • SHAFT, SHOULDERED .................................................. 1
11 XDFZZ 61080 030 947 00 • HUB, BODY .................................................................... 1
12 XDFZZ 61080 030 632 01 • FLYWHEEL, ENGINE ..................................................... 1
15 XDFZZ 61080 006 350 00 • IMPELLER, FAN AXIAL .................................................. 1
16 XDFZZ 57328 N09339 • SOCKET HEAD CAP SCREW.......................................... 4
17 XDFZZ 61080 038 039 01 • FLYWHEEL HOUS ING ................................................... 1
END OF FIGURE
15-1
info_mart
TM 5-4310-393-24P
Figure 16. Cowling Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 16 COWLING ASSEMBLY

2 XDFZZ 61080 501 481 00 • WASHER, FLAT ............................................................. 2
3 XDFZZ 61080 500 646 00 • SCREW, MACHINE ........................................................ 1
4 XDFZZ 61080 400 282 00 • NUT, SELF-LOCKING, HEX ............................................ 1
5 XDFZZ 61080 035 654 00 • GROMMET, NONMETALLIC ........................................... 1
6 XDFZZ 61080 030 666 01 • BAFFLE, AIR FLOW, DIESEL ENGINE ............................ 1
END OF FIGURE
16-1
info_mart
TM 5-4310-393-24P
Figure 17. Fuel Injector

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 17 FUEL INJECTOR
1 PAOZZ 57328 TIE-0008 • STRAP, TIE-DOWN, ELECTRICAL EQUIP ....................... 2

2 XDOZZ 57328 CMP-0003 • CLAMP, HOSE ................................................................ 1
3 PAOZZ 61080 034 936 00 • HOSE, NONMETALLIC ................................................... 1
5 XDOZZ 61080 502 764 00 • TEE, TUBE...................................................................... 1
6 PAOZZ 61080 034 933 00 • HOSE, NONMETALLIC ................................................... 1
7 PAOZZ 61080 034 057 00 • TUBE ASSEMBLY, METAL ............................................. 1
8 XDFZZ 61080 501 444 00 • NUT, PLAIN, HEX ........................................................... 2
9 XDFZZ 61080 034 473 00 • PLATE, MOUNTING ........................................................ 1
10 PAFDD 61080 400 066 00 • INJECTOR ASSEMBLY, FUEL......................................... 1
11 PAFZZ 61080 400 031 00 • GASKET ......................................................................... 1
12 XDFZZ 61080 501 110 00 • STUD, PLAIN ................................................................. 2
END OF FIGURE
17-1
info_mart
TM 5-4310-393-24P
Figure 18. Fuel Injection Pump

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 18 FUEL INJECTION PUMP

2 XDOZZ 61080 034 850 00 • ADAPTER, STRAIGHT, PIPE TO HOSE .......................... 1
3 PAOZZ 61080 500 011 00 • GASKET ........................................................................ 2
4 XDOZZ 61080 006 710 01 • VALVE, CHECK .............................................................. 1
6 PAFDD 61080 400 802 01 • PUMP, FUEL, METERING AND DISTRIBUTING............... 1
7 PAFZZ 61080 040 713 00 • GASKET, 0.10mm .......................................................... 2
PAFZZ 61080 041 022 00 GASKET, 0.20mm .......................................................... 2
PAFZZ 61080 041 023 00 GASKET, 0.30mm .......................................................... 2
8 PAFZZ 61080 032 095 00 • SHIM, 0.15mm ................................................................ 1
PAFZZ 61080 032 097 00 SHIM, 0.30mm................................................................. 1
PAFZZ 61080 041 024 00 SHIM, 0.60mm................................................................. 1
PAFZZ 61080 041 028 00 SHIM, 0.65mm................................................................. 1
PAFZZ 61080 041 025 00 SHIM, 0.90mm................................................................. 1
PAFZZ 61080 032 094 00 SHIM, 0.10mm................................................................. 1
PAFZZ 61080 032 096 00 SHIM, 0.20mm ................................................................ 1
PAFZZ 61080 032 098 00 SHIM, 0.50mm ................................................................ 1
9 XDFZZ 61080 030 640 00 • TAPPET, PUMP, FUEL ................................................... 1
10 XDFZZ 61080 030 626 00 • PLATE, TAPPET ............................................................ 1
11 XDFZZ 61080 500 373 00 • STUD, PLAIN ................................................................. 2
13 XDFZZ 61080 003 624 00 • PUMP, ENGINE PRIMING, HAND DRIVEN ...................... 1
14 PAFZZ 61080 400 228 00 • PACKING, PREFORMED ................................................ 1
END OF FIGURE
18-1
info_mart
TM 5-4310-393-24P
Figure 19. Hand Cranking Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 19 HAND CRANKING ASSEMBLY
1 XDOZZ 57328 HAN-0029 • CRANK, HAND................................................................ 1

3 XDFZZ 61080 003 137 01 • HOUSING, MECHANICAL DRIVE ................................... 1
4 PAFZZ 61080 032 100 00 • GASKET ......................................................................... 1
5 XDFFF 61080 004 106 11 • GEAR, SPUR .................................................................. 1
6 XDFZZ 61080 032 620 00 •• PIN, LOCK ...................................................................... 1
7 PAFZZ 61080 502 524 00 •• PACKING, ASSEMBLY .................................................... 1
8 XDFZZ 61080 400 190 00 •• BEARING, ROLLER......................................................... 1
9 XDFZZ 61080 400013 00 • WASHER, FLAT.............................................................. 1
10 XDFZZ 61080 400 329 00 • BUSHING, SLEEVE ........................................................ 1
END OF FIGURE
19-1
info_mart
TM 5-4310-393-24P
Figure 20. Cylinder Head

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 20 CYLINDER HEAD
1 XDFFZ 61080 030 915 00 • STRAP, RETAINING ....................................................... 1

2 XDOZZ 61080 500 234 00 • NUT, PLAIN, HEX............................................................ 6
3 XDOZZ 61080 500 035 00 • WASHER, SPRING, TENSION......................................... 2
4 XDOZZ 61080 003 138 02 • COVER, ENGINE PUPPET VALVE ROCKER................... 1
5 XDFFF 61080 003 620 04 •• VALVE, CHECK .............................................................. 1
6 XDFFF 61080 035 890 00 • LABEL, DIRECTION ARROW .......................................... 1
7 XDOZZ 61080 032 039 02 • GASKET ......................................................................... 1
9 XDFZZ 61080 034 578 00 • BRACKET, ENGINE ACCESSORY................................... 1
10 XDFZZ 61080 030 665 01 • COVER, ACCESS .......................................................... 1
11 XDFZZ 61080 030 664 01 • COVER, ACCESS .......................................................... 1
12 XDOZZ 61080 030 220 01 • SETSCREW.................................................................... 1
15 XDOZZ 61080 030 037 00 • SETSCREW.................................................................... 2
16 XDOZZ 61080 030 600 02 • BRACKET, DOUBLE ANGLE .......................................... 1
17 XDOZZ 61080 030 615 01 • SHAFT, STRAIGHT ........................................................ 1
18 XDFZZ 61080 006 142 01 • ROCKER ARM ASSEMBLY, ENGINE............................... 1
19 XDFZZ 61080 006 143 01 • ROCKER ARM ASSEMBLY, ENGINE............................... 1
20 XDFZZ 61080 034 301 00 •• BUSHING, SLEEVE ........................................................ 2
21 XDFZZ 61080 030 925 00 • CLAMP, ROCKER SHAFT .............................................. 1
22 XDFZZ 61080 500 437 00 • PLUG, PIPE ................................................................... 1
23 PAFZZ 61080 009 076 01 • CYLINDER HEAD DIESEL ENGINE ................................. 1
24 PAFZZ 61080 007 401 21 • CYLINDER HEAD DIESEL ENGINE ................................. 1
25 PAFZZ 61080 037 703 00 • GASKET, 0.30m.............................................................. 1
PAFZZ 61080 035 818 00 GASKET, 0.40mm ................................................................ 1
PAFZZ 61080 035 819 00 GASKET, 0.50mm ................................................................ 1
PAFZZ 61080 035 820 00 GASKET, 0.60mm ................................................................ 1
PAOZZ 61080 035 821 00 GASKET, 0.70mm ................................................................ 1
PAOZZ 61080 035 822 00 GASKET, 0.80mm ................................................................ 1
26 XDOZZ 61080 031 719 10 •• COLLET, MACHINE ........................................................ 2
27 MOOZZ 61080 030 605 01 •• SEAT, HELICAL COMPRESSION SPRING....................... 2
28 XDOZZ 61080 032 081 00 •• SPRING, HELICAL COMPRESSION ................................ 2
29 XDFZZ 61080 032 084 00 •• SEAT, HELICAL COMPRESSION SPRING....................... 2
30 XDFZZ 61080 032 080 01 •• VALVE PLATE ................................................................ 2
31 XDFZZ 61080 037 538 00 ••• SPACER, RING .............................................................. 2
32 XDFZZ 61080 032 082 10 ••• GUIDE, VALVE STEM...................................................... 2
33 XDOZZ 61080 500 357 00 ••• PIN, SPRING .................................................................. 2
34 XDOZZ 61080 021 373 02 ••• SEAT, VALVE ................................................................ 1
35 XDFZZ 61080 032 080 01 •• VALVE, POPPET, ENGINE ............................................. 2
36 PAOZZ 61080 500 238 00 •• NUT, PLAIN, HEX ........................................................... 1
37 MOOZZ 61080 030 611 00 •• PIN, STRAIGHT, THREADED ......................................... 1
38 XDOZZ 61080. 500 426 00 •• WASHER, SPRING TENSION.......................................... 1
39 XDFZZ 61080 030 638 00 •• PIN, SHOULDER, HEADLESS ........................................ 1
40 XDFZZ 61080 501 542 00 •• PACKING, PREFORMED ................................................ 1
41 XDFZZ 61080 500 341 00 •• PIN, SPRING .................................................................. 1
20-1
info_mart
TM 5-4310-393-24P
42 XDFZZ 61080 007 468 00 •• LEVER, MANUAL CONTROL .......................................... 1

43 XDOZZ 61080 035 706 00 •• CAM, CONTROL ............................................................ 1
44 MOOZZ 61080 501 543 00 • PACKING, PREFORMED................................................. 1
45 XDOZZ 61080 003 618 01 • CUP, PRIMING ............................................................... 1
46 XDFZZ 61080 500 011 00 • GASKET ........................................................................ 1
47 XDFZZ 61080 032 077 01 • STUD, RECESSED AND STEPPED................................. 2
48 XDFZZ 61080 032 076 00 • STUD, RECESSED AND STEPPED................................. 2
END OF FIGURE
20-2
info_mart
TM 5-4310-393-24P
Figure 21. Push-rods and Camfollowers Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 21 PUSH-RODS AND CAMFOLLOWERS ASSEMBLY
1 XDFZZ 61080 030 639 01 • PUSH ROD, ENGINE POPPET VALVE ............................ 1
2 XDFZZ 61080 009 026 00 • PUSH ROD, ENGINE POPPET VALVE ........................... 1
3 PAFZZ 61080 502 880 00 • PACKING, PREFORMED ................................................ 4
5 XDFZZ 61080 032 090 02 • CONNECTING, LINK, RIGID ........................................... 2
6 XDFZZ 61080 031 851 00 • SPRING, HELICAL, COMPRESSION .............................. 2
7 XDFZZ 61080 030 597 00 • SHAFT, SHOULDERED .................................................. 1
8 XDFZZ 61080 030 634 01 • TAPPET, ENGINE POPPET, VALVE ............................... 1
9 XDFZZ 61080 030 633 01 • TAPPET, ENGINE POPPET, VALVE ............................... 1
END OF FIGURE
21-1
info_mart
TM 5-4310-393-24P
Figure 22. Timing Gears and Cover

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 22 TIMING GEARS AND COVER
1 XDFZZ 61080 500 292 00 • SCREW, CAP, HEX HEAD.................................................. 4

2 PAFZZ 61080 500 010 00 • GASKET ............................................................................ 4
3 XDFZZ 61080 500 538 00 • SCREW, CAP, HEX HEAD.................................................. 2
4 XDFZZ 61080 500 245 00 • NUT, HEX........................................................................... 1
5 XDFZZ 61080 500 032 00 • WASHER, WAVE ............................................................... 1
6 XDFZZ 61080 031 124 10 • GEAR ............................................................................... 1
7 XDFZZ 61080 034 300 00 • CAMSHAFT........................................................................ 1
8 XDFZZ 61080 400 379 00 • RING, RETAINING.............................................................. 1
9 XDFZZ 61080 032 780 00 • SHAFT SPACER ............................................................... 1
10 XDFDD 61080 500 622 00 • BEARING UNIT, ROLLER .................................................. 1
11 XDFZZ 61080 400 337 00 •• SHAFT SPACER ................................................................ 1
12 XDFFF 61080 003 623 10 • TIMING COVER................................................................. 1
13 PAFZZ 61080 032 092 02 • TIMING COVER GASKET .................................................. 1
14 XDFZZ 61080 032 093 00 • SPACER............................................................................ 1
15 XDFZZ 61080 400 368 00 • BEARING .......................................................................... 1
16 XDFZZ 61080 031 693 00 • DOWEL PIN....................................................................... 2
17 XDFZZ 61080 500 129 00 • BEARING UNIT, BALL ........................................................ 1
18 PAFZZ 61080 036 124 00 •• INTERIM RING................................................................... 1
19 XDFZZ 61080 400 329 00 • BUSHING........................................................................... 1
END OF FIGURE
22-1
info_mart
TM 5-4310-393-24P
Figure 23. Connecting Rod, Piston and Cylinder

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 23 CONNECTING ROD, PISTON AND CYLINDER
1 XDFZZ 61080 009 127 00 • PISTON & CYLINDER ASSEMBLY .................................. 1

2 PAFZZ 61080 035 883 00 • PISTON CYLINDER ........................................................ 1
3 XDFZZ 61080 009 041 03 • PISTON ASSEMBLY ...................................................... 1
4 XDFZZ 61080 500 206 00 • RETAINING RING .......................................................... 2
5 XDFZZ 61080 501 075 00 • WRIST PIN...................................................................... 1
6 XDFZZ 61080 009 043 00 • PISTON RING SET ......................................................... 1
7 XDFZZ 61080 003 613 01 • CONNECTING ROD ASSEMBLY .................................... 1
8 XDFZZ 61080 033 937 00 • SOCKET HEAD CAP SCREW.......................................... 2
9 XDFZZ 61080 032 069 00 • BUSHING ....................................................................... 1
10 XDFDD 61080 032 067 00 • BEARING, SHELL .......................................................... 1
END OF FIGURE
23-1
info_mart
TM 5-4310-393-24P
Figure 24. Throttle Control

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 24 THROTTLE CONTROL
1 XDFZZ 61080 501 444 00 • HEX NUT ....................................................................... 1

2 PAFZZ 61080 500 042 00 • SETSCREW, SOCKET ................................................... 1
3 XDFZZ 61080 500 235 00 • HEX NUT ....................................................................... 2
4 XDFZZ 61080 032 060 00 • THROTTLE LEVER ........................................................ 1
5 XDFZZ 61080 032 061 00 • HEX NUT ....................................................................... 1
6 XDFZZ 61080 031 462 01 • FRICTION DISC ............................................................. 1
7 XDFZZ 61080 500 349 00 • SPRING DOWEL SLEEVE .............................................. 2
8 XDFZZ 61080 500 343 00 • SPRING DOWEL SLEEVE .............................................. 2
9 XDFZZ 61080 004 273 03 • THROTTLE CONTROL SHAFT ....................................... 1
10 XDFDD 61080 500 036 00 • WAVE WASHER ............................................................ 1
11 XDFZZ 61080 400 223 00 • O-RING .......................................................................... 2
12 XDFFF 61080 032 057 04 • SPRING, GOVERNOR .................................................... 1
13 PAFZZ 61080 003 087 04 • GOVERNOR LEVER ....................................................... 1
14 XDFZZ 61080 032 058 00 • CAP ............................................................................... 1
15 XDFZZ 61080 500 229 00 • HEX NUT ....................................................................... 1
16 XDFZZ 61080 031 049 01 • PLATE ........................................................................... 1
17 XDFZZ 61080 400 217 00 • O-RING .......................................................................... 1
18 PAFZZ 61080 030 604 03 • ECCENTRIC PIN ............................................................ 1
END OF FIGURE
24-1
info_mart
TM 5-4310-393-24P
Figure 25. Impeller Guards

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 25 IMPELLER GUARDS
1 XDFZZ 57328 SCR-0106 • HEX HEAD CAP SCREW ................................................ 6

2 PAFZZ 57328 WAS-0024 • WASHER, FLAT ............................................................. 6
3 XDFZZ 61080 037 085 00 • BLOWER GUARD, LEFT ................................................ 1
4 XDFZZ 61080 036 853 00 • BLOWER GUARD, RIGHT .............................................. 1
END OF FIGURE
25-1
info_mart
TM 5-4310-393-24P
Figure 26. Crankshaft

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 26 CRANKSHAFT
1 XDFZZ 61080 030 648 01 • GEAR/SHAFT ................................................................. 1

2 PAFZZ 61080 500 111 00 • SHAFT KEY ................................................................... 1
3 XDFZZ 61080 030 045 01 • DISC............................................................................... 1
4 XDFZZ 61080 007 420 00 • BALL SHELL .................................................................. 1
5 XDFZZ 61080 031 700 02 • INNER RACE ................................................................. 1
XDFZZ 61080 500 100 00 • PRECISION BALL ........................................................... 4
7 XDFZZ 61080 030 066 02 • BALL DISC ..................................................................... 1
8 XDFZZ 61080 032 066 00 • SPACER......................................................................... 1
9 XDFZZ 61080 500 255 00 • HEX HEAD CAP SCREW................................................. 4
10 XDFDD 61080 032 059 01 • PLATE ........................................................................... 2
11 XDFZZ 61080 005 630 01 •• COVER, BEARING .......................................................... 1
12 XDFFF 61080 501 540 00 • O-RING........................................................................... 1
13 PAFZZ 61080 500 471 00 • ROLLER BEARING.......................................................... 1
14 XDFZZ 61080 500 362 00 • RETAINING RING ........................................................... 1
15 XDFZZ 61080 033 804 00 • SHAFT SPACER, 0.10mm ............................................... 1
61080 033 805 00 SHAFT SPACER, 0.20mm ............................................... 1
61080 033 806 00 SHAFT SPACER, 0.30mm ............................................... 1
61080 033 807 00 SHAFT SPACER, 0.40 m ................................................ 1
61080 033 808 00 SHAFT SPACER, 0.50mm ............................................... 1
16 XDFZZ 61080 500 477 00 • ROLLER BEARING.......................................................... 1
17 XDFZZ 61080 003 612 02 • CRANKSHAFT ............................................................... 1
END OF FIGURE
26-1
info_mart
TM 5-4310-393-24P
Figure 27. Crankcase

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 27 CRANKCASE
1 XDFFZ 61080 400 397 01 • CAP ............................................................................... 1

2 XDOZZ 61080 500 621 00 •• SETSCREW, SOCKET ................................................... 1
3 XDOZZ 61080 030 690 04 •• OIL FILL PLUG................................................................ 1
4 XDOZZ 61080 501 538 00 •• O-RING .......................................................................... 2
5 XDFFF 61080 036 584 00 •• ADAPTER, PIPE ............................................................. 1
6 XDFFF 61080 003 088 02 •• OIL DIPSTICK ASSEMBLY ............................................. 1
7 XDOZZ 61080 400 220 00 •• O-RING........................................................................... 2
8 XDFZZ 61080 503 244 00 •• DIPSTICK SEAL ............................................................. 1
9 XDFZZ 61080 031 691 03 •• OIL DRAIN PLUG............................................................ 1
10 XDFZZ 61080 500 015 00 •• COPPER GASKET.......................................................... 1
11 XDFZZ 61080 500 292 00 •• HEX HEAD CAP SCREW................................................. 8
12 XDOZZ 61080 500 029 00 •• WAVE WASHER ............................................................ 8
13 XDOZZ 61080 030 621 00 •• MOUNTING FOOT........................................................... 2
14 XDOZZ 61080 500 504 00 •• SOCKET HEAD CAP SCREW.......................................... 4
15 XDOZZ 61080 032 062 00 •• CAP ............................................................................... 4
16 XDOZZ 61080 032 056 02 •• COVER .......................................................................... 1
17 XDOZZ 61080 400 238 00 •• GASKET ........................................................................ 1
18 XDFZZ 61080 400 025 00 •• POP RIVET .................................................................... 4
19 XDFZZ 61080 033 255 04 •• LABEL, ENGINE DATA PLATE ........................................ 1
20 XDFZZ 61080 033 225 10 •• LABEL, STARTING INSTRUCTIONS ................................ 1
21 XDFZZ 61080 009 128 00 •• ENGINE CRANKCASE ................................................... 1
END OF FIGURE
27-1
info_mart
TM 5-4310-393-24P
Figure 28. Pressure Maintaining Valve

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
GROUP 03 PURIFICATION SYSTEM
FIGURE 28 PRESSURE MAINTAINING VALVE
1 XDFFZ 57328 CON-0039SS • HOSE CONNECTOR ...................................................... 1

2 PAOZZ 57328 CON-0035SS •• MALE CONNECTOR ....................................................... 2
3 XDOZZ 57328 VAL-0037 •• BLEED VALVE ............................................................... 1
4 XDOZZ 57328 CON-0030SS •• MALE CONNECTOR ....................................................... 1
5 XDFFF 57328 CON-0042SS •• EQUAL CROSS .............................................................. 1
6 XDFFF 57328 VAL-0176 •• CHECK VALVE .............................................................. 1
7 XDOZZ 57328 LBL-0498 •• LABEL, "BAUER CHECK VALVE" .................................... 1
8 XDFZZ 57328 CON-0017SS •• HEX NIPPLE CONNECTOR ............................................ 1
9 XDFZZ 57328 NUT-0005 •• HEX LOCK NUT ............................................................. 2
10 XDFZZ 57328 WAS-0017 •• FLAT WASHER............................................................... 4
11 XDFZZ 57328 SCR-0021 •• HEX HEAD CAP SCREW................................................. 2
12 PAOZZ 57328 VAL-0053 •• PRESSURE MAINTAINING VALVE ................................. 1
13 XDOZZ 0PH81 511 •• NUT, HEX........................................................................ 1
14 XDOZZ 0PH81 510-1 •• PRESSURE ADJUSTING SCREW ................................... 1
15 PAOZZ 0PH81 324-7 •• SPRING, COMPRESSION............................................... 1
16 XDOZZ 0PH81 568 •• SPRING GUIDE .............................................................. 1
17 XDOZZ 0PH81 324-8 •• O-RING........................................................................... 1
18 XDFZZ 0PH81 214 •• VALVE POPPET ............................................................. 1
19 XDFZZ 0PH81 324-9 •• PRECISION BALL .......................................................... 1
20 XDFZZ 0PH81 321 •• VALVE SEAT ................................................................. 1
21 XDFZZ 0PH81 324-10 •• O-RING........................................................................... 1
22 XDFZZ 57328 LBL-0433 •• LABEL, "MAXIMUM WORKING."...................................... 1
23 PAFZZ 0PH81 212 •• VALVE BODY ................................................................. 1
END OF FIGURE
28-1
info_mart
TM 5-4310-393-24P
Figure 29. Purifier Chamber

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 29 PURIFIER CHAMBER
1 XDFFZ 57328 TUB-0239 • CONNECTING TUBE ...................................................... 1

2 XDOZZ 57328 TUB-0238 •• CONNECTING TUBE ...................................................... 1
3 XDOZZ 57328 CON-0030SS •• MALE CONNECTOR ...................................................... 2
4 XDOZZ 57328 VAL-0007 •• CHECK VALVE .............................................................. 1
5 XDFFF 57328 LBL-0498 •• LABEL "BAUER CHECK VALVE" .................................... 1
6 XDFFF 57328 CON-0005SS •• O-RING CONNECTOR ................................................... 2
7 XDOZZ 57328 PLU-0063 •• SNAP-IN HOLE PLUG .................................................... 4
8 XDFZZ 57328 NUT-0008 •• HEX NUT........................................................................ 4
9 XDFZZ 57328 WAS-0033 •• SPLIT LOCK WASHER.................................................... 4
10 XDFZZ 57328 WAS-0017 •• FLAT WASHER .............................................................. 4
11 XDFZZ 57328 CMP-0002 •• T-BOLT CLAMP .............................................................. 2
12 PAOZZ 57328 058814 •• PURIFIER CHAMBER ASSEMBLY .................................. 1
13 PAOZZ 57328 061231 •• PURIFIER HEAD ............................................................ 1
14 PAOZZ 57328 061075 •• PURIFIER HOUSING ...................................................... 1
15 XDOZZ 57328 N04736 •• BACK-UP RING............................................................... 2
16 XDOZZ 57328 N04735 •• O-RING........................................................................... 2
17 XDOZZ 57328 012293 •• TOOL POST SCREW ...................................................... 2
18 XDFZZ 57328 061237 •• PURIFIER COVER .......................................................... 1
19 XDFZZ 57328 058731 •• BOTTOM PLUG .............................................................. 1
20 XDFZZ 57328 N03333 •• POP RIVET .................................................................... 3
21 XDFZZ 57328 N03334 •• FLAT HEAD RIVET ......................................................... 1
22 XDFZZ 57328 065963 •• LABEL, "PURIFIER MFG. DATA" .................................... 1
23 XDFZZ 57328 090762 •• LABEL, "WARNING RELIEVE PRESSURE ....................... 1
24 XDFZZ 57328 013762 •• LABEL, "MADE IN GERMANY" ....................................... 1
25 XDFZZ 57328 068416 •• PURIFIER CARTRIDGE .................................................. 1
END OF FIGURE
29-1
info_mart
TM 5-4310-393-24P
Figure 30. Final Separator

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
FIGURE 30 FINAL SEPARATOR
1 XDFFZ 57328 TUB-0241 • CONNECTING TUBE....................................................... 1

2 XDOZZ 57328 CON-0061SS •• MALE CONNECTOR ...................................................... 1
3 XDOZZ 57328 N01316 •• COPPER GASKET ......................................................... 3
4 XDOZZ 57328 N00052 •• HEX HEAD PIPE PLUG .................................................. 2
5 XDFFF 57328 CON-0030SS •• MALE CONNECTOR ...................................................... 1
6 XDFFF 57328 ADP-0021SS •• PIPE ADAPTER .............................................................. 1
7 XDOZZ 57328 N04602 •• FITTING GASKET........................................................... 1
8 XDFZZ 57328 LBL-0300 •• LABEL, "RELIEF VALVE SETTING" ................................ 1
9 XDFZZ 57328 VAL-0169 •• SAFETY VALVE .............................................................. 1
10 XDFZZ 57328 ADP-0020SS •• PIPE ADAPTER .............................................................. 1
11 XDFZZ 57328 N04499 •• FITTING GASKET........................................................... 1
12 XDOZZ 57328 011430 •• MANUAL DRAIN VALVE.................................................. 1
13 XDOZZ 57328 NUT-0119 •• HEX LOCK NUT.............................................................. 2
14 XDOZZ 57328 WAS-0040 •• FLAT WASHER............................................................... 2
15 XDOZZ 57328 058165 •• U-BOLT .......................................................................... 1
16 XDOZZ 57328 SCR-0156 •• SOCKET HEAD CAP SCREW.......................................... 2
17 XDOZZ 57328 064013 •• FLANGE ADAPTER ........................................................ 1
18 XDFZZ 57328 N04882 •• O-RING........................................................................... 1
19 XDFZZ 57328 063999 •• FLANGE ELBOW ........................................................... 1
20 XDFZZ 57328 091150 •• FINAL MOISTURE SEPARATOR ..................................... 1
21 XDFZZ 57328 090393 •• SEPARATOR HEAD........................................................ 1
22 XDFZZ 57328 N03333 •• POP RIVET..................................................................... 3
23 XDFZZ 57328 N03334 •• FLAT HEAD RIVET.......................................................... 1
24 XDFZZ 5-7328 065963 •• LABEL, SEPARATOR MFG. DATA .................................. 1
25 XDFZZ 57328 090394 •• SEPARATOR BOTTOM PLUG ......................................... 1
26 XDFZZ 57328 N04586 •• O-RING........................................................................... 2
27 PBFZZ 57328 090395 •• SEPARATOR ELEMENT ................................................. 1
28 XDFZZ 57328 013762 •• LABEL, "MADE IN GERMANY" ....................................... 1
29 XDFZZ 57328 090392 •• SEPARATOR HOUSING.................................................. 1
END OF FIGURE
30-1
info_mart
TM 5-4310-393-24P
Figure 31. Instruments and Control Panel Assembly (Sheet 1 of 2)

info_mart
TM 5-4310-393-24P
Figure 31. Instruments and Control Panel Assembly (Sheet 2 of 2)

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
GROUP 04 INSTRUMENTS AND CONTROL PANEL ASSEMBLY
FIGURE 31 INSTRUMENTS AND CONTROL PANEL ASSEMBLY
1 XCOFF 57328 18782-9 • INSTRUMENT GROUP ................................................... 1

2 PAOZZ 57328 18782-AY •• VIBRATION HOURMETER.............................................. 2
3 XDOZZ 57328 RIV-0001 •• STAINLESS STEEL RIVET ............................................. 6
4 XDOZZ 57328 LBL-0003 •• LABEL "HOURMETER OFF" ........................................... 2
5 XDFFF 57328 LBL-0518 •• LABEL, INSTRUMENT PANEL......................................... 1
6 XDFFF 57328 18782-BK •• HEX HEAD CAP SCREW ................................................ 8
7 XDOZZ 57328 18782-BF •• SOCKET HEAD CAP SCREW ......................................... 8
8 XDOZZ 57328 WAS-0040 •• FLAT WASHER............................................................... 16
9 XDFZZ 57328 WAS-0041 •• SPLIT LOCK WASHER ................................................... 16
10 XDFZZ 57328 18782-BD •• VIBRATION ELIMINATOR................................................ 8
11 XDFZZ 57328 BRK-0343 •• HOURMETER PANEL ..................................................... 1
12 XDFZZ 57328 GAG-0009SLT •• PRESSURE GAUGE........................................................ 2
13 XDOZZ 57328 CON-0019SS •• FEMALE CONNECTOR................................................... 2
16 XDOZZ 57328 PNL-0601 •• INSTRUMENT PANEL..................................................... 1
END OF FIGURE
31-1
info_mart
TM 5-4310-393-24P
Figure 32. Diesel Fuel Tank Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
GROUP 05 DIESEL FUEL TANK ASSEMBLY
FIGURE 32 DIESEL FUEL TANK ASSEMBLY
1 XDFFZ 57328 18782-18 • EL TANK INS TALLATION ................................................ 1

2 XDOZZ 61080 500 061 00 •• BANJO BOLT.................................................................. 1
3 XDOZZ 61080 500 009 00 •• FLAT WASHER .............................................................. 2
4 XDOZZ 61080 500 157 00 •• SWIVEL FITTING ............................................................ 1
5 XDFFF 57328 CMP-0007 •• WORM GEAR HOSE CLAMP .......................................... 1
6 XDFFF 57328 HOS-R-0029 •• FUEL HOSE ................................................................... 1
7 XDOZZ 61080 500 064 00 •• BANJO BOLT ................................................................. 1
8 XDFZZ 61080 500 012 00 •• FLAT WASHER .............................................................. 2
9 XDFZZ 61080 500 159 00 •• SWIVEL FITTING ............................................................ 1
10 XDFZZ 57328 CMP-0003 •• WORM GEAR HOSE CLAMP .......................................... 1
11 XDFZZ 57328 HOS-R-0031 •• FUEL HOSE.................................................................... 1
13 PAOZZ 61080 003 291 02 •• FUEL FILTER.................................................................. 1
14 XDOZZ 61080 400 327 00 •• FUEL CAP....................................................................... 1
16 XDOZZ 61080 005 627 00 •• FUEL TANK STRAP ASSEMBLY .................................... 2
17 XDOZZ 61080 007 785 00 •• FUEL TANK STRAP ....................................................... 2
18 XDFZZ 61080 032 005 00 •• RUBBER STRIP .............................................................. 2
19 XDFZZ 61080 031 886 00 •• FUELTANKSPACER........................................................ 4
20 XDFZZ 61080 006 667 00 •• FUEL TANK .................................................................... 1
END OF FIGURE
32-1
info_mart
TM 5-4310-393-24P
Figure 33. Charging Whip Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
GROUP 06 CHARGING WHIP ASSEMBLY
FIGURE 33 CHARGING WHIP ASSEMBLY
1 XDFFZ 57328 18782-19 • FILL WHIP ASSEMBLY ................................................... 1

2 XDOZZ 57328 CVR-0002 •• GAUGE PROTECTOR..................................................... 1
3 XDOZZ 57328 GAG-0046 •• PRESSURE GAUGE........................................................ 1
4 XDOZZ 57328 CON-0042SS •• EQUAL CROSS .............................................................. 1
5 XDFFF 57328 CON-0017SS •• HEX NIPPLE CONNECTOR............................................. 1
6 XDFFF 57328 YOK-0001 •• SCUBA FILL YOKE ......................................................... 1
7 XDOZZ 57328 CVR-0097 •• DUST COVER................................................................. 1
8 XDFZZ 57328 VAL-0169 •• SAFETY VALVE ............................................................. 1
9 XDFZZ 57328 LBL-0300 •• LABEL "RELIEF VALVE" ................................................. 1
10 XDFZZ 57328 VAL-0006 •• NEEDLE VALVE ............................................................. 1
11 XDFZZ 57328 CON-0039SS •• PIPE ADAPTER .............................................................. 1
12 XDOZZ 57328 18782-AU •• NYLON BRAIDED CORD ................................................ 10
13 XDOZZ 57328 HOS-0056 •• TITEFLEX HOSE ............................................................ 1
14 XDOZZ 57328 18782-AT •• NYLON COATED CABLE ................................................ 17
15 XDOZZ 57328 CON-0128 •• WIRE CRIMP ................................................................. 4
16 XDOZZ 57328 18782-AS •• SWIVEL SNAP SHACKLE ............................................... 2
END OF FIGURE
33-1
info_mart
TM 5-4310-393-24P
Figure 34. Intake Hose Assembly

info_mart
SECTION 2 TM 5-4310-393-24P
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
GROUP 07 INTAKE HOSE ASSEMBLY
FIGURE 34 INTAKE HOSE ASSEMBLY
1 XDFFZ 57328 18782-5 • INTAKE HOSE ASSEMBLY ............................................. 1

2 XDOZZ 57328 CMP-0025 •• WORM GEAR HOSE CLAMP........................................... 2
3 XDOZZ 57328 057691 •• PRE-FILTER .................................................................. 1
4 XDOZZ 57328 18782-AN •• HOSE CUFF ................................................................... 2
5 XDFFF 57328 18782-Z •• FLEXIBLE INTAKE HOSE ............................................... 15
END OF FIGURE
34-1
info_mart
TM 5-4310-393-24P
SECTION 3 Special Tools List
Figure 35. Special Tools List (Sheet 1 of 2)

info_mart
TM 5-4310-393-24P
Figure 35. Special Tools List (Sheet 2 of 2)

info_mart
TM 5-4310-393-24P
SECTION 3 SPECIAL TOOLS LIST
SECTION 3
(1) (2) (3) (4) (5) (6)
ITEM SMR PART
NO CODE CAGEC NUMBE R DESCRIPTION AND USABLE ON CODES (UOC) QTY
SPECIAL TOOLS LIST
FIG. 35 SPECIAL TOOLS LIST
1 XDFFZ 57328 011365 • VALVE ASSEMBLY JIG .................................................. 1

2 PFOZZ 57328 057493 • PISTON RING CLAMP .................................................... 1
3 XDOZZ 57328 057499 • PISTON RING CLAMP .................................................... 1
4 XDOZZ 57328 004555 • VALVE EXTRACTION TOOL ........................................... 1
5 XDFFF 57328 057491 • TEST PRESSURE GAUGE ............................................. 1
6 XDFFF 57328 057492 • TEST PRESSURE GAUGE ............................................. 1
7 PFOZZ 57328 WRH-0002 • PURIFIER WRENCH ...................................................... 1
8 XDFZZ 1CV05 6006NMA • TORQUE WRENCH ........................................................ 1
9 XDFZZ 61080 618 305 00 • SPECIAL TOOL FOR GOVERNOR SPRING .................... 1
10 XDFZZ 61080 666 067 00 • IMPACT MANDREL ........................................................ 1
11 XDFZZ 61080 606 000 00 • ADJUSTING WRENCH ................................................... 1
12 PFOZZ 61080 666.069 00 • IMPACT MANDREL ........................................................ 1
13 PFOZZ 61080 666 074 00 • MOUNTING DEVICE ...................................................... 1
14 PFOZZ 61080 665 030 01 • SPILL DEVICE FOR FUEL PUMP ................................... 1
15 PFOZZ 61080 666 324 00 • EXTRACTOR TOOL ....................................................... 1
16 XDOZZ 61080 604 628 00 • INJECTION EQUIPMENT TEST DEVICE ......................... 1
17 XDOZZ 61080 612 099 00 • SOCKET WITH PIN ........................................................ 1
18 XDFZZ 61080 666 418 00 • MOUNTING DEVICE ...................................................... 1
19 XDFZZ 61080 666 425 00 • PUNCH .......................................................................... 1
20 XDFZZ 61080 668 335 00 • SPECIAL SOCKET WRENCH (30mm) ............................. 1
21 XDFZZ 61080 612 752 00 • RETAINING BRACKET ................................................... 1
22 XDFZZ 61080 612 087 00 • DIAL GAUGE 1/100mm ................................................... 1
END OF FIGURE
35-1
info_mart
TM 5-4310-393-24P
SECTION 4 CROSS-REFERENCE INDEXES
NATIONAL STOCK NUMBER INDEX
5310 00-013-7712 1 2 5305 01-077-9725 20 15

5330 00-110-0734 10 16 5360 01-078-3790 20 28
5330 00-166-8396 11 28 3040 01-079-1258 21 7
5330 00-166-8403 11 19 2910 01-079-8052 17 9
5330 00-173-3086 10 19 5310 01-080-0033 16 4
5365 00-490-6426 15 1 5330 01-080-1776 18 3
3030 00-811-7019 4 13 20 46
2940 00-848-6043 3 5 5310 01-080-4987 20 2
5320 00-860-6605 11 8 5360 01-080-9455 21 6
29 20 5340 01-082-7936 20 1
30 22 5340 01-082-9574 20 16
4310 01-005-3612 6 7 5305 01-084-5283 9 19
5330 01-006-9433 6 8 5330 01-084-5331 9 23
5330 01-007-4802 11 17 5310 01-086-7866 14 7
5330 01-007-4818 10 5 5330 01-091-1256 8 11
3120 01-066-3942 20 20 4730 01-093-6236 20 22
2815 01-068-2400 20 24 5310 01-099-9532 15 6
3040 01-068-2869 20 42 5330 01-100-0638 18 14
4710 01-068-5332 21 5 4810 01-104-4319 8 13
3040 01-069-1676 20 43 6930 01-116-6844 1 33
5305 01-069-8906 15 13 5975 01-127-9543 5 1
5330 01-070-1123 20 40 5975 01-127-9543 17 1
5307 01-070-2148 20 47 5310 01-168-1520 5 5
5315 01-070-3402 20 33 5310 01-168-1520 9 14
5307 01-070-6470 20 48 5310 01-168-1520 10 2
5310 01-070-7116 18 12 11 2
5310 01-070-7215 15 14 5330 01-233-3247 3 4
5307 01-070-9174 17 12 5330 01-255-1055 11 5
5307 01-071-1326 13 6 5310 01-264-6234 17 11
5307 01-071-1326 14 4 2910 01-264-6235 18 6
5307 01-071-1327 18 11 5310 01-264-6236 14 1
2815 01-072-1094 21 8 5310 01-264-6239 19 9
2815 01-072-1095 20 18 5310 01-264-6248 20 8
2990 01-072-1776 20 9 5330 01-264-6288 19 4
2815 01-072-3119 18 10 5330 01-264-6291 20 25
2815 01-072-3120 20 4 4820 01-264-6294 18 4
2815 01-072-3121 16 6 2910 01-264-6339 17 10
2815 01-072-3197 20 19 4710 01-264-6340 17 7
4820 01-072-3307 20 05 2815 01-265-1752 20 45
2910 01-072-8350 18 9 2815 01-265-1753 20 23
5305 01-073-5931 20 12 5330 01-265-1926 20 44
2815 01-073-5932 21 10 3120 01-265-1945 19 10
5340 01-073-5933 20 27 3120 01-265-1945 22 19
5310 01-074-1496 21 4 5330 01-267-2307 19 7
5330 01-074-1502 20 7 5305 01-274-1092 15 9
5330 01-074-1503 20 25 4820 01-282-2499 6 4
5330 01-074-2105 20 25 4820 01-282-2500 7 7
5330 01-074-2106 20 25 4820 01-282-2501 5 11
5330 01-074-2107 20 25 2910 01-282-2512 18 13
5330 01-074-2108 20 25 4330 01-282-5176 9 20
5330 01-074-2109 22 2 4310 01-282-6943 10 11
5310 01-074-6878 20 26 3110 01-282-9169 11 16
I-1
info_mart
TM 5-4310-393-24P
5330 01-282-9269 10 17 5330 12-156-4523 7 5

5330 01-287-6529 3 6 8 3
2815 01-297-4451 20 26 30 3
2815 01-317-9877 21 2 5307 12-156-4582 10 7
2815 01-321-5525 21 1 5310 12-156-4657 13 1
4820 01-321-9894 7 2 5305 12-156-4917 4 14
4310 01-322-2125 10 9 5310 12-156-4991 17 8
2805 01-322-5768 5 6 20 13
5330 01-323-5461 10 6 24 1
3110 01-326-2871 11 15 5310 12-156-4996 1 30
4820 01-327-0030 9 8 5310 12-156-6471 1 25
5305 01-345-0572 14 5 4820 12-166-2100 8 12
4730 01-345-7673 9 3 4310 12-166-2256 7 10
5330 01-352-1982 6 9 5330 12-166-3679 9 9
5305 01-368-2957 5 10 5305 12-166-9343 19 2
4730 01-407-0881 14 8 5305 12-167-5386 4 19
5310 12-124-0187 1 26 5330 12-170-8127 9 4
5310 12-124-0579 20 14 4330 12-174-6848 9 22
5305 12-124-4359 15 16 4310 12-179-0643 9 21
4730 12-124-7273 11 30 5305 12-181-2507 9 15
5305 12-126-5285 4 17 5305 12-181-2507 11 1
5310 12-126-6731 20 38 5310 12-184-8509 4 3
5307 12-131-3717 10 20 5305 12-186-0141 8 7
5330 12-132-7547 11 10 5310 12-186-0147 8 5
5305 12-142-0989 5 4 5330 12-188-3929 18 8
5305 12-142-2956 11 6 5330 12-188-3930 18 8
5305 12-142-2957 6 5 5330 12-188-3931 18 8
5305 12-142-2957 7 8 5330 12-188-3932 18 8
5305 12-142-2959 8 8 5330 12-188-3933 18 8
5305 12-142-5841 15 5 5305 12-189-3684 4 12
22 3
5305 12-142-5938 11 20
5310 12-142-8157 11 21
5310 12-142-8158 4 15
5310 12-142-8173 20 3
5310 12-143-1138 9 12
5310 12-144-6214 18 5
24 15
5330 12-145-1487 5 7
5310 12-145-5638 4 2
5330 12-145-6538 11 29
5310 12-146-0644 20 36
5305 12-146-2633 11 11
5310 12-149-4353 16 2
5310 12-151-4627 13 2
5305 12-152-6465 16 1
5310 12-154-3038 9 11
5315 12-156-4485 20 41
5330 12-156-4509 8 6
I-2
info_mart
TM 5-4310-393-24P
NATIONAL STOCK NUMBER AND PART NUMBER INDEX
CAGEC P/N FSC NIIN Fig Item
OPH81 214 28 18
OPH81 321 28 20
OPH81 324-10 28 21
OPH81 324-7 28 15
OPH81 324-8 28 17
OPH81 324-9 28 19
OPH81 510-1 28 14
OPH81 511 28 13
OPH81 586 28 16
1CV05 6006NMA 35 8
57328 001866 5330 00-173-3086 10 19
57328 001867 5330 01-007-4818 10 5
57328 002010 5330 12-145-1487 5 7
57328 003110 5330 01-323-5461 10 6
57328 003196 11 13
57328 004479 5330 12-166-3679 9 9
57328 0045559 35 4
57328 006540 10 3
57328 007790 4810 01-104-4319 8 13
57328 008264 7 3
57328 009884 4310 01-005-3612 6 7
57328 010528 3 3
57328 010670 4820 01-321-9894 7 2
57328 010875 10 4
57328 011365 35 1
57328 011430 9 10
30 12
57328 011656 4820 01-327-0030 9 8
57328 012293 29 17
57328 012560 11 23
57328 012754 4 16
57328 012770 3 8
57328 012771 3 2
57328 012784 4330 12-174-6848 9 22
57328 012785 4310 12-179-0643 9 21
57328 012786 5305 01-084-5283 9 19
57328 012841 4310 12-166-2256 7 10
57328 013662 4 5
57328 013663 4 6
57328 013666 4 18
57328 013757 5330 01-287-6529 3 6
57328 013758 3 1
57328 013762 9 24
30 28
57328 013930 9 18
57328 013937 9 17
57328 014030 11 14
57328 014117 8 10
57328 014118 8 9
57328 014121 4820 12-166-2100 8 12
I-3
info_mart
TM 5-4310-393-24P
57328 014123 7 9
57328 014139 4 20
57328 014150 9 24
57328 014368 9 13
57328 014370 4 21
57328 014564 4 11
57328 014582 4820 01-282-2500 7 7
57328 014583 4820 01-282-2499 6 4
57328 014605 4 7
57328 014624 4 1
57328 014874 11 32
57328 014878 11 4
57328 014886 11 18
57328 014887 11 22
57328 014888 11 12
57328 014892 11 26
57328 014907 6 6
57328 014998 11 3
57328 055097 9 25
57328 056141 10 18
57328 056189 10 13
57328 057491 35 5
57328 057492 35 6
57328 057493 35 2
57328 057499 35 3
57328 057691 34 3
57328 058138 4820 01-282-2501 5 11
57328 058159 11 7
57328 058165 30 15
57328 058731 29 19
57328 058814 29 12
57328 058991 4 10
57328 061075 29 14
57328 061231 29 13
57328 061237 29 18
57328 063999 30 19
57328 064013 30 17
57328 065094 10 12
57328 065963 29 22
57328 065963 30 24
57328 066934 10 14
57328 067275 11 9
57328 067612 9 16
57328 068416 29 25
57328 069948 10 8
57328 069949 10 10
57328 069950 10 21
57328 069951 6 3
57328 069954 8 4
57328 069955 7 6
57328 069957 4 9
57328 069959 9 1
57328 069960 4 22
57328 069965 5 8
57328 069966 5 3
I-4
info_mart
TM 5-4310-393-24P
57328 071065 5305 12-186-0141 8 7

57328 073270 11 31
57328 090392 30 29
57328 090393 30 21
57328 090394 30 25
57328 090395 30 27
57328 090762 29 23
57328 091150 30 20
57328 18782-17 1 1
57328 18782-18 32 1
57328 18782-19 33 1
57328 18782-5 34 1
57328 18782-9 31 1
57328 18782-AC 1 3
57328 18782-AH 1 7
57328 18782-AN 34 4
57328 18782-AP 14 9
57328 18782-AS 33 16
57328 18782-AT 33 14
57328 18782-AU 33 12
57328 18782-AW 1 40
57328 18782-AY 31 2
57328 18782-BD 31 10
57328 18782-BE 1 9
57328 18782-BF 31 7
57328 18782-BH 5305 01-345-0572 14 5
57328 18782-BJ 12 1
57328 18782-BK 31 6
57328 18782-Z 34 5
57328 ADP-0020SS 30 10
57328 ADP-0021SS 30 6
57328 BAS-0068 1 29
57328 BAS-0085 1 28
57328 BET-0021 3030 00-811-7019 4 13
57328 BRK-0343 31 11
57328 BUS-0011 5365 00-490-6426 15 1
57328 CMP-0002 29 11
57328 CMP-0003 17 2
18 1
32 10
57328 CMP-0007 17 4
32 5
57328 CMP-0025 34 2
57328 CMP-0053 4730 01-407-0881 14 8
57328 CON-0005SS 29 6
57328 CON-0017SS 28 8
33 5
57328 CON-0019SS 31 13
57328 CON-0030SS 28 4
29 3
30 5
57328 CON-0035SS 28 2
57328 CON-0039SS 28 1
33 11
57328 CON-0042SS 28 5
I-5
info_mart
TM 5-4310-393-24P
33 4
57328 CON-0061SS 30 2
57328 CON-0076SS 9 5
57328 CON-0128 33 15
57328 CON-0266SS 6 1
7 1
8 1
9 2
57328 CVR-0002 33 2
57328 CVR-0097 33 7
57328 EDG-0001 6930 01-116-6844 1 33
57328 ELL-0010SS 5 9
57328 ENG-0040 12 4
57328 FRM-0199 1 6
57328 FRM-0200 1 5
57328 GAG-0009SLT 31 12
57328 GAG-0046 33 3
57328 GRD-0196 1 34
57328 GRD-0256 1 16
57328 HAN-0029 19 1
57328 HOS-0056SS 33 13
57328 HOS-R-0029 32 6
57328 HOS-R-0031 32 11
57328 KC-FH US GOV'T 2 4
57328 LBL-0003 31 4
57328 LBL-0300 30 8
33 9
57328 LBL-0433 28 22
57328 LBL-0498 28 5
29 5
57328 LBL-0508 1 37
57328 LBL-0509 1 10
57328 LBL-0510 1 41
57328 LBL-0511 1 36
57328 LBL-0512 1 38
57328 LBL-0513 1 18
57328 LBL-0514 1 21
57328 LBL-0515 1 20
57328 LBL-0516 1 35
57328 LBL-0517 1 22
57328 LBL-0518 31 5
57328 LBL-0530 1 19
57328 LBL-0663 1 11
57328 MUF-0018 14 2
57328 N00052 30 4
57328 N00070 2940 00-848-6043 3 5
57328 N00083 2805 01-322-5768 5 6
57328 N00215 5307 12-156-4582 10 7
57328 N00220 5330 01-007-4802 11 17
57328 N00293 5330 12-145-6538 11 29
57328 N01282 5305 12-142-2959 8 8
57328 N01316 5330 12-156-4523 7 5
57328 N01316 5330 12-156-4523 8 3
30 3
57328 N01386 15 7
I-6
info_mart
TM 5-4310-393-24P
57328 N01437 5305 12-126-5285 4 17

57328 N01539 5330 01-352-1982 6 9
57328 N01547 1 31
57328 N02169 5330 01-006-9433 6 8
57328 N02320 5330 00-110-0734 10 16
57328 N02726 4330 01-282-5176 9 20
57328 N02789 5330 01-091-1256 8 11
57328 N02862 5310 12-143-1138 9 12
57328 N03026 5310 12-142-8157 11 21
57328 N03207 11 27
57328 N03292 1 27
57328 N03333 5320 00-860-6605 11 8
29 20
30 22
57328 N03334 29 21
57328 N03334 30 23
57328 N03374 3 7
57328 N03407 5305 01-368-2957 5 10
57328 N03521 5330 00-166-8403 11 19
57328 N03556 5330 01-084-5331 9 23
57328 N03623 5310 12-186-0147 8 5
57328 N03625 5330 12-156-4509 8 6
57328 N03702 3110 01-282-9169 11 16
57328 N03703 3110 01-326-2871 11 15
57328 N03705 5330 01-255-1055 11 5
57328 N03707 4730 12-124-7273 11 30
57328 N03712 5330 00-166-8396 11 28
57328 N03726 5330 12-132-7547 11 10
57328 N03736 11 24
57328 N03737 6 2
11 25
57328 N03856 4310 01-322-2125 10 9
57328 N04051 5330 12-170-8127 9 4
57328 N04064 5330 01-282-9269 10 17
57328 N04065 5307 12-131-3717 10 20
57328 N04158 4310 01-282-6943 10 11
57328 N04451 5330 01-233-3247 3 4
57328 N04499 30 11
57328 N04586 30 26
57328 N04602 30 7
57328 N04735 29 16
57328 N04736 29 15
57328 N04882 30 18
57328 N09339 5305 12-124-4359 15 16
57328 N15843 9 7
57328 N20083 7 4
57328 N20501 8 2
57328 N23755 10 15
57328 NUT-0002 5310 01-086-7866 14 7
57328 NUT-0005 28 9
57328 NUT-0008 29 8
57328 NUT-0055SS 9 6
57328 NUT-0062 5310 12-154-3038 9 11
57328 NUT-0076 5310 12-156-4996 1 30
57328 NUT-0079 2 1
I-7
info_mart
TM 5-4310-393-24P
57328 NUT-0118 5310 12-145-5638 4 2

57328 NUT-0119 10 1
57328 NUT-0119 30 13
57328 NUT-0124 5310 00-013-7712 1 2
57328 NUT-0133 1 12
57328 PLU-0028 4730 01-345-7673 9 3
57328 PLU-0063 29 7
57328 PNL-0601 31 16
57328 RIV-0001 1 8
31 3
57328 SCR-0004 12 3
57328 SCR-0011 1 13
15 3
57328 SCR-0021 28 11
57328 SCR-0025 5305 12-181-2507 9 15
11 1
57328 SCR-0051 4 4
57328 SCR-0065 5305 12-146-2633 11 11
57328 SCR-0066 1 39
57328 SCR-0080 2 3
57328 SCR-0106 25 1
57328 SCR-0110 5305 12-189-3684 4 12
57328 SCR-0115SS 1 23
57328 SCR-0116SS 1 24
57328 SCR-0127 1 4
57328 SCR-0136 5305 12-142-0989 5 4
57328 SCR-0145 5305 12-142-5938 11 20
57328 SCR-0156 30 16
57328 SCR-0159 5305 12-156-4917 4 14
57328 SCR-0179 5305 12-142-2956 11 6
57328 SCR-0180 5305 12-142-2957 6 5
7 8
57328 SCR-0192 5305 12-167-5386 4 19
57328 SCR-0211 1 32
57328 SHE-0127 15 4
57328 SHF-0023 15 8
57328 SUP-0157 1 17
57328 TIE-0008 5975 01-127-9543 5 1
17 1
57328 TUB-0236 31 15
57328 TUB-0237 31 14
57328 TUB-0238 29 2
57328 TUB-0239 29 1
57328 TUB-0241 30 1
57328 TUB-0339 5 2
57328 UNN-0020SS 4 23
57328 UNN-0050SS 4 8
57328 VAL-0006 33 10
57328 VAL-0007 29 4
57328 VAL-0037 28 3
57328 VAL-0053 28 12
57328 VAL-0169 30 9
33 8
57328 VAL-0176 28 6
57328 WAS-0001 5310 12-142-8158 1 25
I-8
info_mart
TM 5-4310-393-24P
57328 WAS-0003 4 15
57328 WAS-0016 1 15
12 2
57328 WAS-0017 1 14
28 10
29 10
57328 WAS-0021 5310 01-168-1520 5 5
57328 WAS-0021 5310 01-168-1520 9 14
57328 WAS-0021 5310 01-168-1520 10 2
57328 WAS-0021 5310 01-168-1520 11 2
57328 WAS-0024 5310 12-184-8509 4 3
57328 WAS-0024BR 25 2
57328 WAS-0030 5310 12-124-0187 1 26
57328 WAS-0031 5310 12-156-6471 1 25
57328 WAS-0033 15 2
57328 WAS-0033 29 9
57328 WAS-0040 2 2
57328 WAS-0040 30 14
57328 WAS-0040 31 8
57328 WAS-0041 31 9
57328 WRH-0002 35 7
57328 YOK-0001 33 6
61080 003 087 04 24 13
61080 003 088 02 27 6
61080 003 137 01 19 3
61080 003 138 02 2815 01-072-3120 20 4
61080 003 291 02 32 13
61080 003 612 02 26 17
61080 003 613 01 23 7
61080 003 618 01 2815 01-265-1752 20 45
61080 003 620 04 4820 01-072-3307 20 5
61080 003 623 10 22 10
61080 003 624 00 2910 01-282-2512 18 13
61080 004 106 11 19 5
61080 004 273 03 24 9
61080 005 627 00 32 16
61080 005 630 01 26 11
61080 006 142 01 2815 01-072-1095 20 18
61080 006 143 01 2815 01-072-3197 20 19
61080 006 350 00 15 15
61080 006 667 00 32 20
61080 006 710 01 4820 01-264-6294 18 4
61080 007 401 21 2815 01-068-2400 20 24
61080 007 420 00 26 4
61080 007 468 00 3040 01-068-2869 20 42
61080 007 785 00 32 17
61080 009 026 00 2815 01-317-9877 21 2
61080 009 041 03 23 3
61080 009 043 00 23 6
61080 009 076 01 2815 01-265-1753 20 23
61080 009 127 00 23 1
61080 009 128 00 27 21
61080 012 846 00 13 5
61080 012 861 00 14 3
I-9
info_mart
TM 5-4310-393-24P
61080 021 373 02 20 34

61080 030 037 00 5305 01-077-9725 20 15
61080 030 045 01 26 3
61080 030 066 02 26 7
61080 030 220 01 5305 01-073-5931 20 12
61080 030 597 00 3040 01-079-1258 21 7
61080 030 600 02 5340 01-082-9574 20 16
61080 030 604 03 24 18
61080 030 605 01 5340 01-073-5933 20 27
61080 030 611 00 20 37
61080 030 615 01 20 17
61080 030 621 00 27 13
61080 030 626 00 2815 01-072-3119 18 10
61080 030 632 01 15 12
61080 030 633 01 21 9
61080 030 634 01 2815 01-072-1094 21 8
61080 030 638 00 20 39
61080 030 639 01 2815 01-321-5525 21 1
61080 030 640 00 2910 01-072-8350 18 9
61080 030 648 01 26 1
61080 030 664 01 20 11
61080 030 665 01 20 10
61080 030 666 01 2815 01-072-3121 16 6
61080 030 690 04 27 3
61080 030 915 00 5340 01-082-7936 20 1
61080 030 925 00 2815 01-073-5932 20 21
61080 030 947 00 15 11
61080 031 049 01 24 16
61080 031 124 00 22 6
61080 031 462 01 24 6
61080 031 691 03 27 9
61080 031 693 00 22 16
61080 031 698 00 5310 01-074-6878 21 10
61080 031 700 02 26 5
61080 031 719 10 2815 01-297-4451 20 26
61080 031 731 00 5310 12-124-0579 20 14
61080 031 851 00 5360 01-080-9455 21 6
61080 031 886 00 32 19
61080 032 005 00 32 18
61080 032 056 02 27 16
61080 032 057 04 24 12
61080 032 058 00 24 14
61080 032 059 01 26 10
61080 032 060 00 24 4
61080 032 061 00 24 5
61080 032 062 00 27 15
61080 032 066 00 26 8
61080 032 067 00 23 10
61080 032 069 00 23 9
61080 032 076 00 5307 01-070-6470 20 48
61080 032 077 01 5307 01-070-2148 20 47
61080 032 080 01 20 30
20 35
61080 032 081 00 5360 01-078-3790 20 28
61080 032 082 10 20 32
I-10
info_mart
TM 5-4310-393-24P
61080 032 084 00 20 29

61080 032 089 02 5330 01-074-1502 20 7
61080 032 090 02 4710 01-068-5332 21 5
61080 032 091 01 5310 01-074-1496 21 4
61080 032 092 02 22 13
61080 032 093 00 22 14
61080 032 094 00 5330 12-188-3933 18 8
61080 032 095 00 5330 12-188-3932 18 8
61080 032 096 00 5330 12-188-3931 18 8
61080 032 097 00 5330 12-188-3930 18 8
61080 032 098 00 5330 12-188-3929 18 8
61080 032 100 00 5330 01-264-6288 19 4
61080 032 620 00 19 6
61080 032 780 00 22 9
61080 033 255 04 27 19
61080 033 255 10 27 20
61080 033 804 00 26 15
61080 033 805 00 26 15
61080 033 806 00 26 15
61080 033 807 00 26 15
61080 033 808 00 26 15
61080 033 937 00 23 8
61080 033 963 01 13 8
61080 034 057 00 4710 01-264-6340 17 7
61080 034 300 00 22 7
61080 034 301 00 3120 01-066-3942 20 20
61080 034 473 00 2910 01-079-8052 17 9
61080 034 578 00 2990 01-072-1776 20 9
61080 034 850 00 18 2
61080 034 933 00 17 6
61080 034 936 00 17 3
61080 035 377 00 32 15
61080 035 654 00 16 5
61080 035 706 00 3040 01-069-1676 20 43
61080 035 818 00 5330 01-074-2105 20 25
61080 035 819 00 5330 01-074-2106 20 25
61080 035 820 00 5330 01-074-2107 20 25
61080 035 821 00 5330 01-074-1503 20 25
61080 035 822 00 5330 01-074-2108 20 25
61080 035 883 00 23 2
61080 035 890 00 20 6
61080 036 124 00 22 18
61080 036 311 02 13 7
61080 036 584 00 27 5
61080 036 853 00 25 4
61080 037 085 00 25 3
61080 037 538 00 20 31
61080 037 663 00 5310 01-264-6248 20 8
61080 037 703 00 5330 01-264-6291 20 25
61080 038 039 01 15 17
61080 040 713 00 18 7
61080 041 022 00 18 7
61080 041 023 00 18 7
61080 041 024 00 18 8
61080 041 025 00 18 8
I-11
info_mart
TM 5-4310-393-24P
61080 041 028 00 18 8

61080 400 013 00 5310 01-264-6239 19 9
61080 400 025 00 27 18
61080 400 031 00 5310 01-264-6234 17 11
61080 400 066 00 2910 01-264-6339 17 10
61080 400 190 00 19 8
61080 400 217 00 24 17
61080 400 220 00 27 7
61080 400 223 00 24 11
61080 400 228 00 5330 01-100-0638 18 14
61080 400 238 00 27 17
61080 400 278 00 5310 01-070-7215 15 14
61080 400 282 00 5310 01-080-0033 16 4
61080 400 327 00 32 14
61080 400 329 00 3120 01-265-1945 19 10
61080 400 329 00 3120 01-265-1945 22 19
61080 400 337 00 22 11
61080 400 356 00 5305 01-069-8906 15 13
61080 400 368 00 22 15
61080 400 379 00 22 8
61080 400 397 01 27 1
61080 400 802 01 2910 01-264-6235 18 6
61080 400 816 00 5310 01-264-6236 14 1
61080 400 994 00 13 3
61080 400 995 00 13 4
61080 500 009 00 32 3
61080 500 010 00 5330 01-074-2109 22 2
61080 500 011 00 5330 01-080-1776 18 3
20 46
61080 500 012 00 32 8
61080 500 015 00 26 10
61080 500 028 00 5310 01-099-9532 15 6
61080 500 029 00 15 10
61080 500 029 00 27 12
61080 500 032 00 22 5
61080 500 035 00 5310 12-142-8173 20 3
61080 500 036 00 24 10
61080 500 042 00 24 2
61080 500 061 00 32 2
61080 500 064 00 32 7
61080 500 100 00 26 6
61080 500 111 00 26 2
61080 500 129 00 22 17
61080 500 157 00 32 4
61080 500 159 00 32 9
61080 500 206 00 23 4
61080 500 229 00 5310 12-144-6214 18 5
24 15
61080 500 230 00 5310 12-156-4657 13 1
61080 500 234 00 5310 01-080-4987 20 2
61080 500 235 00 24 3
61080 500 238 00 5310 12-146-0644 20 36
61080 500 245 00 22 4
61080 500 246 00 5310 01-070-7116 18 12
61080 500 255 00 26 9
I-12
info_mart
TM 5-4310-393-24P
61080 500 292 00 22 1

61080 500 292 00 27 11
61080 500 341 00 5315 12-156-4485 20 41
61080 500 343 00 24 8
61080 500 349 00 24 7
61080 500 357 00 5315 01-070-3402 20 33
61080 500 362 00 26 14
61080 500 372 00 5307 01-071-1326 13 6
14 1
61080 500 373 00 5307 01-071-1327 18 11
61080 500 426 00 5310 12-126-6731 20 38
61080 500 437 00 4730 01-093-6236 20 22
61080 500 471 00 26 13
61080 500 477 00 26 16
61080 500 504 00 27 14
61080 500 516 00 5305 12-152-6465 16 1
61080 500 534 00 5305 12-166-9343 19 2
61080 500 538 00 5305 12-142-5841 15 5
61080 500 538 00 5305 12-142-5841 22 3
61080 500 548 00 5305 01-274-1092 15 9
61080 500 621 00 27 2
61080 500 622 00 22 10
61080 500 627 00 32 12
61080 500 646 00 16 3
61080 501 075 00 23 5
61080 501 110 00 5307 01-070-9174 17 12
61080 501 444 00 5310 12-156-4991 17 8
61080 501 444 00 5310 12-156-4991 20 13
24 1
61080 501 481 00 5310 12-149-4353 16 2
61080 501 538 00 27 4
61080 501 540 00 26 12
61080 501 542 00 5330 01-070-1123 20 40
61080 501 543 00 5330 01-265-1926 20 44
61080 502 085 00 5310 12-151-4627 13 2
61080 502 524 00 5330 01-267-2307 19 7
61080 502 764 00 17 5
61080 502 880 00 21 3
61080 503 244 00 27 8
61080 604 628 00 35 16
61080 606 000 00 35 11
61080 612 087 00 35 22
61080 612 099 00 35 17
61080 612 752 00 35 21
61080 618 305 00 35 9
61080 665 030 01 35 14
61080 666 067 00 35 10
61080 666 069 00 35 12
61080 666 074 00 35 13
61080 666 324 00 35 15
61080 666 418 00 35 18
61080 666 425 00 35 19
61080 668 335 00 35 20
OPH81 212 28 23
I-13
info_mart
TM 5-4310-393-24P
Figure and Item Number to Part Number Cross Reference
Fig Item FSC NIIN CAGEC P/N
1 1 57328 18782-17
1 2 5310 00-013-7712 57328 NUT-0124
1 3 57328 18782-AC
1 4 57328 SCR-0127
1 5 57328 FRM-0200
1 6 57328 FRM-0199
1 7 57328 18782-AH
1 8 57328 RIV-0001
1 9 57328 18782-BE
1 10 57328 LBL-0509
1 11 57328 LBL-0663
1 12 57328 NUT-0133
1 13 57328 SCR-0011
1 14 57328 WAS-0017
1 15 57328 WAS-0016
1 16 57328 GRD-0256
1 17 57328 SUP-0157
1 18 57328 LBL-0513
1 19 57328 LBL-0530
1 20 57328 LBL-0515
1 21 57328 LBL-0514
1 22 57328 LBL-0517
1 23 57328 SCR-0115SS
1 24 57328 SCR-0116SS
1 25 5310 12-142-8158 57328 WAS-0001
1 25 5310 12-156-6471 57328 WAS-0031
1 26 5310 12-124-0187 57328 WAS-0030
1 27 57328 N03292
1 28 57328 BAS-0085
1 29 57328 BAS-0068
1 30 5310 12-156-4996 57328 NUT-0076
1 31 57328 N01547
1 32 57328 SCR-0211
1 33 6930 01-116-6844 57328 EDG-0001
1 34 57328 GRD-0196
1 35 57328 LBL-0516
1 36 57328 LBL-0511
1 37 57328 LBL-0508
1 38 57328 LBL-0512
1 39 57328 SCR-0066
1 40 57328 18782-AW
1 41 57328 LBL-0510
2 1 57328 NUT-0079
2 2 57328 WAS-0040
2 3 57328 SCR-0080
2 4 57328 KC-FH US GOV’T
3 1 57328 013758
3 2 57328 012771
3 3 57328 010528
3 4 5330 01-233-3247 57328 N04451
3 5 2940 00-848-6043 57328 N00070
3 6 5330 01-287-6529 57328 013757
3 7 57328 N03374
I-14
info_mart
TM 5-4310-393-24P
3 8 57328 012770
4 1 57328 014624
4 2 5310 12-145-5638 57328 NUT-0118
4 3 5310 12-184-8509 57328 WAS-0024
4 4 57328 SCR-0051
4 5 57328 013662
4 6 57328 013663
4 7 57328 014605
4 8 57328 UNN-0050SS
4 9 57328 069957
4 10 57328 058991
4 11 57328 014564
4 12 5305 12-189-3684 57328 SCR-0110
4 13 3030 00-811-7019 57328 BET-0021
4 14 5305 12-156-4917 57328 SCR-0159
4 15 57328 WAS-0003
4 16 57328 012754
4 17 5305 12-126-5285 57328 N01437
4 18 57328 013666
4 19 5305 12-167-5386 57328 SCR-0192
4 20 57328 014139
4 21 57328 014370
4 22 57328 069960
4 23 57328 UNN-0020SS
5 1 5975 01-127-9543 57328 TIE-0008
5 2 57328 TUB-0339
5 3 57328 069966
5 4 5305 12-142-0989 57328 SCR-0136
5 5 5310 01-168-1520 57328 WAS-0021
5 6 2805 01-322-5768 57328 N00083
5 7 5330 12-145-1487 57328 002010
5 8 57328 069965
5 9 57328 ELL-0010SS
5 10 5305 01-368-2957 57328 N03407
5 11 4820 01-282-2501 57328 058138
6 1 57328 CON-0266SS
6 2 57328 N03737
6 3 57328 069951
6 4 4820 01-282-2499 57328 014583
6 5 5305 12-142-2957 57328 SCR-0180
6 6 57328 014907
6 7 4310 01-005-3612 57328 009884
6 8 5330 01-006-9433 57328 N02169
6 9 5330 01-352-1982 57328 N01539
7 1
7 2 4820 01-321-9894 57328 010670
7 3 57328 008264
7 4 57328 N20083
7 5 5330 12-156-4523 57328 N01316
7 6 57328 069955
7 7 4820 01-282-2500 57328 014582
7 8
7 9 57328 014123
7 10 4310 12-166-2256 57328 012841
8 1
I-15
info_mart
TM 5-4310-393-24P
8 2 57328 N20501
8 3 5330 12-156-4523 57328 N01316
8 4 57328 069954
8 5 5310 12-186-0147 57328 N03623
8 6 5330 12-156-4509 57328 N03625
8 7 5305 12-186-0141 57328 071065
8 8 5305 12-142-2959 57328 N01282
8 9 57328 014118
8 10 57328 014117
8 11 5330 01-091-1256 57328 N02789
8 12 4820 12-166-2100 57328 014121
8 13 4810 01-104-4319 57328 007790
9 1 57328 069959
9 2
9 3 4730 01-345-7673 57328 PLU-0028
9 4 5330 12-170-8127 57328 N04051
9 5 57328 CON-0076SS
9 6 57328 NUT-0055SS
9 7 57328 N15843
9 8 4820 01-327-0030 57328 011656
9 9 5330 12-166-3679 57328 004479
9 10 57328 011430
9 11 5310 12-154-3038 57328 NUT-0062
9 12 5310 12-143-1138 57328 N02862
9 13 57328 014368
9 14 5310 01-168-1520 57328 WAS-0021
9 15 5305 12-181-2507 57328 SCR-0025
9 16 57328 067612
9 17 57328 013937
9 18 57328 013930
9 19 5305 01-084-5283 57328 012786
9 20 4330 01-282-5176 57328 N02726
9 21 4310 12-179-0643 57328 012785
9 22 4330 12-174-6848 57328 012784
9 23 5330 01-084-5331 57328 N03556
9 24 57328 013762
9 24 57328 014150
9 25 57328 055097
10 1 57328 NUT-0119
10 2 5310 01-168-1520 57328 WAS-0021
10 3 57328 006540
10 4 57328 010875
10 5 5330 01-007-4818 57328 001867
10 6 5330 01-323-5461 57328 003110
10 7 5307 12-156-4582 57328 N00215
10 8 57328 069948
10 9 4310 01-322-2125 57328 N03856
10 10 57328 069949
10 11 4310 01-282-6943 57328 N04158
10 12 57328 065094
10 13 57328 056189
10 14 57328 066934
10 15 57328 N23755
10 16 5330 00-110-0734 57328 N02320
10 17 5330 01-282-9269 57328 N04064
I-16
info_mart
TM 5-4310-393-24P
10 18 57328 056141
10 19 5330 00-173-3086 57328 001866
10 20 5307 12-131-3717 57328 N04065
10 21 57328 069950
11 1
11 2 5310 01-168-1520 57328 WAS-0021
11 3 57328 014998
11 4 57328 014878
11 5 5330 01-255-1055 57328 N03705
11 6 5305 12-142-2956 57328 SCR-0179
11 7 57328 058159
11 8 5320 00-860-6605 57328 N03333
11 9 57328 067275
11 10 5330 12-132-7547 57328 N03726
11 11 5305 12-146-2633 57328 SCR-0065
11 12 57328 014888
11 13 57328 003196
11 14 57328 014030
11 15 3110 01-326-2871 57328 N03703
11 16 3110 01-282-9169 57328 N03702
11 17 5330 01-007-4802 57328 N00220
11 18 57328 014886
11 19 5330 00-166-8403 57328 N03521
11 20 5305 12-142-5938 57328 SCR-0145
11 21 5310 12-142-8157 57328 N03026
11 22 57328 014887
11 23 57328 012560
11 24 57328 N03736
11 25
11 26 57328 014892
11 27 57328 N03207
11 28 5330 00-166-8396 57328 N03712
11 29 5330 12-145-6538 57328 N00293
11 30 4730 12-124-7273 57328 N03707
11 31 57328 073270
11 32 57328 014874
12 1 57328 18782-BJ
12 2
12 3 57328 SCR-0004
12 4 57328 ENG-0040
13 1 5310 12-156-4657 61080 500 230 00
13 2 5310 12-151-4627 61080 502 085 00
13 3 61080 400 994 00
13 4 61080 400 995 00
13 5 61080 012 846 00
13 6 5307 01-071-1326 61080 500 372 00
13 7 61080 036 311 02
13 8 61080 033 963 01
14 1 5310 01-264-6236 61080 400 816 00
14 2 57328 MUF-0018
14 3 61080 012 861 00
14 4 61080 500 372 00
14 5 5305 01-345-0572 57328 18782-BH
14 6 57328 WAS-0016
14 7 5310 01-086-7866 57328 NUT-0002
I-17
info_mart
TM 5-4310-393-24P
14 8 4730 01-407-0881 57328 CMP-0053

14 9 57328 18782-AP
15 1 5365 00-490-6426 57328 BUS-0011
15 2 57328 WAS-0033
15 3
15 4 57328 SHE-0127
15 5 5305 12-142-5841 61080 500 538 00
15 6 5310 01-099-9532 61080 500 028 00
15 7 57328 N01386
15 8 57328 SHF-0023
15 9 5305 01-274-1092 61080 500 548 00
15 10 61080 500 029 00
15 11 61080 030 947 00
15 12 61080 030 632 01
15 13 5305 01-069-8906 61080 400 356 00
15 14 5310 01-070-7215 61080 400 278 00
15 15 61080 006 350 00
15 16 5305 12-124-4359 57328 N09339
15 17 61080 038 039 01
16 1 5305 12-152-6465 61080 500 516 00
16 2 5310 12-149-4353 61080 501 481 00
16 3 61080 500 646 00
16 4 5310 01-080-0033 61080 400 282 00
16 5 61080 035 654 00
16 6 2815 01-072-3121 61080 030 666 01
17 1
17 2 57328 CMP-0003
17 3 61080 034 936 00
17 4 57328 CMP-0007
17 5 61080 502 764 00
17 6 61080 034 933 00
17 7 4710 01-264-6340 61080 034 057 00
17 8 5310 12-156-4991 61080 501 444 00
17 9 2910 01-079-8052 61080 034 473 00
17 10 2910 01-264-6339 61080 400 066 00
17 11 5310 01-264-6234 61080 400 031 00
17 12 5307 01-070-9174 61080 501 11000
18 1
18 2 61080 034 850 00
18 3 5330 01-080-1776 61080 500 011 00
18 4 4820 01-264-6294 61080 006 710 01
18 5 5310 12-144-6214 61080 500 229 00
18 6 2910 01-264-6235 61080 400 802 01
18 7 61080 040 713 00
18 7 61080 041 022 00
18 7 61080 041 023 00
18 8 5330 12-188-3933 61080 032 094 00
18 8 5330 12-188-3932 61080 032 095 00
18 8 5330 12-188-3931 61080 032 096 00
18 8 5330 12-188-3930 61080 032 097 00
18 8 5330 12-188-3929 61080 032 098 00
18 8 61080 041 024 00
18 8 61080 041 025 00
18 8 61080 041 028 00
18 9 2910 01-072-8350 61080 030 640 00
I-18
info_mart
TM 5-4310-393-24P
18 10 2815 01-072-3119 61080 030 626 00

18 11 5307 01-071-1327 61080 500 373 00
18 12 5310 01-070-7116 61080 500 246 00
18 13 2910 01-282-2512 61080 003 624 00
18 14 5330 01-100-0638 61080 400 228 00
19 1 57328 HAN-0029
19 2 5305 12-166-9343 61080 500 534 00
19 3 61080 003 137 01
19 4 5330 01-264-6288 61080 032 100 00
19 5 61080 004 106 11
19 6 61080 032 620 00
19 7 5330 01-267-2307 61080 502 524 00
19 8 61080 400 190 00
19 9 5310 01-264-6239 61080 400 013 00
19 10 3120 01-265-1945 61080 400 329 00
20 1 5340 01-082-7936 61080 030 915 00
20 2 5310 01-080-4987 61080 500 234 00
20 3 5310 12-142-8173 61080 500 035 00
20 4 2815 01-072-3120 61080 003 138 02
20 5 4820 01-072-3307 61080 003 620 04
20 6 61080 035 890 00
20 7 5330 01-074-1502 61080 032 089 02
20 8 5310 01-264-6248 61080 037 663 00
20 9 2990 01-072-1776 61080 034 578 00
20 10 61080 030 665 01
20 11 61080 030 664 01
20 12 5305 01-073-5931 61080 030 220 01
20 13 5310 12-156-4991 61080 501 444 00
20 14 5310 12-124-0579 61080 031 731 00
20 15 5305 01-077-9725 61080 030 037 00
20 16 5340 01-082-9574 61080 030 600 02
20 17 61080 030 615 01
20 18 2815 01-072-1095 61080 006 142 01
20 19 2815 01-072-3197 61080 006 143 01
20 20 3120 01-066-3942 61080 034 301 00
20 21 2815 01-073-5932 61080 030 925 00
20 22 4730 01-093-6236 61080 500 437 00
20 23 2815 01-265-1753 61080 009 076 01
20 24 2815 01-068-2400 61080 007 401 21
20 25 5330 01-074-2105 61080 035 818 00
20 25 5330 01-074-2106 61080 035 819 00
20 25 5330 01-074-2107 61080 035 820 00
20 25 5330 01-074-1503 61080 035 821 00
20 25 5330 01-074-2108 61080 035 822 00
20 25 5330 01-264-6291 61080 037 703 00
20 26 2815 01-297-4451 61080 031 719 10
20 27 5340 01-073-5933 61080 030 605 01
20 28 5360 01-078-3790 61080 032 081 00
20 29 61080 032 084 00
20 30 61080 032 080 01
20 31 61080 037 538 00
20 32 61080 032 082 10
20 33 5315 01-070-3402 61080 500 357 00
20 34 61080 021 373 02
20 35
I-19
info_mart
TM 5-4310-393-24P
20 36 5310 12-146-0644 61080 500 238 00

20 37 61080 030 611 00
20 38 5310 12-126-6731 61080 500 426 00
20 39 61080 030 638 00
20 40 5330 01-070-1123 61080 501 542 00
20 41 5315 12-156-4485 61080 500 341 00
20 42 3040 01-068-2869 61080 007 468 00
20 43 3040 01-069-1676 61080 035 706 00
20 44 5330 01-265-1926 61080 501 543 00
20 45 2815 01-265-1752 61080 003 618 01
20 46
20 47 5307 01-070-2148 61080 032 077 01
20 48 5307 01-070-6470 61080 032 076 00
21 1 2815 01-321-5525 61080 030 639 01
21 2 2815 01-317-9877 61080 009 026 00
21 3 61080 502 880 00
21 4 5310 01-074-1496 61080 032 091 01
21 5 4710 01-068-5332 61080 032 090 02
21 6 5360 01-080-9455 61080 031 851 00
21 7 3040 01-079-1258 61080 030 597 00
21 8 2815 01-072-1094 61080 030 634 01
21 9 61080 030 633 01
21 10 5310 01-074-6878 61080 031 698 00
22 1 61080 500 292 00
22 2 5330 01-074-2109 61080 500 010 00
22 3 5305 12-142-5841 61080 500 538 00
22 4 61080 500 245 00
22 5 61080 500 032 00
22 6 61080 031 124 00
22 7 61080 034 300 00
22 8 61080 400 379 00
22 9 61080 032 780 00
22 10 61080 003 623 10
22 10 61080 500 622 00
22 11 61080 400 337 00
22 13 61080 032 092 02
22 14 61080 032 093 00
22 15 61080 400 368 00
22 16 61080 031 693 00
22 17 61080 500 129 00
22 18 61080 036 124 00
22 19 3120 01-265-1945 61080 400 329 00
23 1 61080 009 127 00
23 2 61080 035 883 00
23 3 61080 009 041 03
23 4 61080 500 206 00
23 5 61080 501 075 00
23 6 61080 009 043 00
23 7 61080 003 613 01
23 8 61080 033 937 00
23 9 61080 032 069 00
23 10 61080 032 067 00
24 1
24 2 61080 500 042 00
24 3 61080 500 235 00
I-20
info_mart
TM 5-4310-393-24P
24 4 61080 032 060 00

24 5 61080 032 061 00
24 6 61080 031 462 01
24 7 61080 500 349 00
24 8 61080 500 343 00
24 9 61080 004 273 03
24 10 61080 500 036 00
24 11 61080 400 223 00
24 12 61080 032 057 04
24 13 61080 003 087 04
24 14 61080 032 058 00
24 15
24 16 61080 031 049 01
24 17 61080 400 217 00
24 18 61080 030 604 03
25 1 57328 SCR-0106
25 2 57328 WAS-0024BR
25 3 61080 037 085 00
25 4 61080 036 853 00
26 1 61080 030 648 01
26 2 61080 500 111 00
26 3 61080 030 045 01
26 4 61080 007 420 00
26 5 61080 031 700 02
26 6 61080 500 100 00
26 7 61080 030 066 02
26 8 61080 032 066 00
26 9 61080 500 255 00
26 10 61080 032 059 01
26 10 61080 500 015 00
26 11 61080 005 630 01
26 12 61080 501 540 00
26 13 61080 500 471 00
26 14 61080 500 362 00
26 15 61080 033 804 00
26 15 61080 033 805 00
26 15 61080 033 806 00
26 15 61080 033 807 00
26 15 61080 033 808 00
26 16 61080 500 477 00
26 17 61080 003 612 02
27 1 61080 400 397 01
27 2 61080 500 621 00
27 3 61080 030 690 04
27 4 61080 501 538 00
27 5 61080 036 584 00
27 6 61080 003 088 02
27 7 61080 400 220 00
27 8 61080 503 244 00
27 9 61080 031 691 03
27 11 61080 500 292 00
27 12 61080 500 029 00
27 13 61080 030 621 00
27 14 61080 500 504 00
27 15 61080 032 062 00
I-21
info_mart
TM 5-4310-393-24P
27 16 61080 032 056 02

27 17 61080 400 238 00
27 18 61080 400 025 00
27 19 61080 033 255 04
27 20 61080 033 255 10
27 21 61080 009 128 00
28 1 57328 CON-0039SS
28 2 57328 CON-0035SS
28 3 57328 VAL-0037
28 4 57328 CON-0030SS
28 5 57328 CON-0042SS
28 5 57328 LBL-0498
28 6 57328 VAL-0176
28 8 57328 CON-0017SS
28 9 57328 NUT-0005
28 10
28 11 57328 SCR-0021
28 12 57328 VAL-0053
28 13 OPH81 511
28 14 OPH81 510-1
28 15 OPH81 324-7
28 16 OPH81 586
28 17 OPH81 324-8
28 18 OPH81 214
28 19 OPH81 324-9
28 20 OPH81 321
28 21 OPH81 324-10
28 22 57328 LBL-0433
28 23 OPH81 212
29 1 57328 TUB-0239
29 2 57328 TUB-0238
29 3
29 4 57328 VAL-0007
29 5
29 6 57328 CON-0005SS
29 7 57328 PLU-0063
29 8 57328 NUT-0008
29 9 57328 WAS-0033
29 10
29 11 57328 CMP-0002
29 12 57328 058814
29 13 57328 061231
29 14 57328 061075
29 15 57328 N04736
29 16 57328 N04735
29 17 57328 012293
29 18 57328 061237
29 19 57328 058731
29 20
29 21 57328 N03334
29 22 57328 065963
29 23 57328 090762
29 25 57328 068416
30 1 57328 TUB-0241
30 2 57328 CON-0061SS
I-22
info_mart
TM 5-4310-393-24P
30 3
30 4 57328 N00052
30 5
30 6 57328 ADP-0021 SS
30 7 57328 N04602
30 8 57328 LBL-0300
30 9 57328 VAL-0169
30 10 57328 ADP-0020SS
30 11 57328 N04499
30 12
30 13 57328 NUT-0119
30 14 57328 WAS-0040
30 15 57328 058165
30 16 57328 SCR-0156
30 17 57328 064013
30 18 57328 N04882
30 19 57328 063999
30 20 57328 091150
30 21 57328 090393
30 22
30 23 57328 N03334
30 24 57328 065963
30 25 57328 090394
30 26 57328 N04586
30 27 57328 090395
30 28
30 29 57328 090392
31 1 57328 18782-9
31 2 57328 18782-AY
31 3
31 4 57328 LBL-0003
31 5 57328 LBL-0518
31 6 57328 18782-BK
31 7 57328 18782-BF
31 8 57328 WAS-0040
31 9 57328 WAS-0041
31 10 57328 18782-BD
31 11 57328 BRK-0343
31 12 57328 GAG-0009SLT
31 13 57328 CON-0019SS
31 14 57328 TUB-0237
31 15 57328 TUB-0236
31 16 57328 PNL-0601
32 1 57328 18782-18
32 2 61080 500 061 00
32 3 61080 500 009 00
32 4 61080 500 157 00
32 5
32 6 57328 HOS-R-0029
32 7 61080 500 064 00
32 8 61080 500 012 00
32 9 61080 500 159 00
32 10
32 11 57328 HOS-R-0031
32 12 61080 500 627 00
I-23
info_mart
TM 5-4310-393-24P
32 13 61080 003 291 02

32 14 61080 400 327 00
32 15 61080 035 377 00
32 16 61080 005 627 00
32 17 61080 007 785 00
32 18 61080 032 005 00
32 19 61080 031 886 00
32 20 61080 006 667 00
33 1 57328 18782-19
33 2 57328 CVR-0002
33 3 57328 GAG-0046
33 4
33 5
33 6 57328 YOK-0001
33 7 57328 CVR-0097
33 8
33 9
33 10 57328 VAL-0006
33 11
33 12 57328 18782-AU
33 13 57328 HOS-0056SS
33 14 57328 18782-AT
33 15 57328 CON-0128
33 16 57328 18782-AS
34 1 57328 18782-5
34 2 57328 CMP-0025
34 3 57328 057691
34 4 57328 18782-AN
34 5 57328 18782-Z
35 1 57328 011365
35 2 57328 057493
35 3 57328 057499
35 4 57328 0045559
35 5 57328 057491
35 6 57328 057492
35 7 57328 WRH-0002
35 8 1CV05 6006NMA
35 9 61080 618 305 00
35 10 61080 666 067 00
35 11 61080 606 000 00
35 12 61080 666 069 00
35 13 61080 666 074 00
35 14 61080 665 030 01
35 15 61080 666 324 00
35 16 61080 604 628 00
35 17 61080 612 099 00
35 18 61080 666 418 00
35 19 61080 666 425 00
35 20 61080 668 335 00
35 21 61080 612 752 00
35 22 61080 612 087 00
I-24
info_mart
By Order of the Secretary of the Army:
DENNIS J. REIMER
General, United States Army
Chief of Staff
Official:
SIGN
JOEL B. HUDSON
Administrative Assistant to the
Secretary of the Army
05504
DISTRIBUTION: To be distributed in accordance with the Initial Distribution Number (IDN) 255545, requirements for TM
5-4310-393-24P.
¶ U.S. GOVERNMENT PRINTING OFFICE: 1999-746-025/80143

info_mart
info_mart
info_mart
info_mart
PIN: 077045-000

Untitled

Uploaded by

Document Informationclick to expand document information

Copyright:

Available Formats

Untitled

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Untitled

Uploaded by

Copyright:

Available Formats

info_mart

UNIT, DIRECT SUPPORT AND GENERAL SUPPORT

DISTRIBUTION STATEMENT A: Approved for public release, distribution is unlimited.

HEADQUARTERS DEPARTMENT OF THE ARMY

TECHNICAL MANUAL HEADQUARTERS

COMPRESSOR UNIT, RECIPROCATING

REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS

APPROVED FOR PUBLIC RELEASE; DISTRIBUTION IS UNLIMITED.

Group 01 Reciprocating Compressor 2-1 2

Group 02 Diesel Engine, ENG-0040 12-1 12

TABLE OF CONTENTS - continued

Group 03 Purification System

Group 05 Diesel Fuel Tank Assembly 32-1 32

Group 06 Charging Whip Assembly 33-1 33

Group 07 Intake Hose Assembly 34-1 34

Section 3 SPECIAL TOOLS LIST 35-1 35

Section 4 CROSS REFERENCE INDEX I-1

ORGANIZATIONAL AND INTERMEDIATE SUPPORT

3. EXPLANATION OF COLUMNS (SECTIONS II AND Ill).

Character 1&2 Character 3 Character 4 Character 5

XB If an "XB" item is not available from salvage, order it using the

Cannibalization or controlled exchange, when authorized, may be used as a source

C - Crew or operator maintenance done within organizational or aviation unit maintenance.

4. EXPLANATION OF COLUMNS (SECTION 4).

a. NATIONAL STOCK NUMBER (NSN) INDEX.

c. FIGURE AND ITEM NUMBER INDEX.

Publication Short Title

6. HOW TO LOCATE REPAIR PARTS.

a. When National Stock Number or Part Number is NOT Known.

b. When National Stock Number or Part Number IS Known.

7. ABBREVIATIONS. Abbreviations used in this manual are listed in MIL-STD-12.

SECTION 2 REPAIR PARTS LIST

FIGURE 1. Frame ad Hardware Assembly (Sheet 1 of 3 )

Figure 1. Frame and Hardware Assembly (Sheet 2 of 3)

Figure 1. Frame and Hardware Assembly (Sheet 3 of 3)

GROUP 00 FRAME AND HARDWARE ASSEMBLY

FIGURE 1 FRAME AND HARDWARE ASSEMBLY

1 XDFFZ 573281 8782-17 • FRAME ASSEMBLY .......................................................... 1

Figure 2. Reciprocating Compressor

GROUP 01 RECIPROCATING COMPRESSOR

FIGURE 2 RECIPROCATING COMPRESSOR

1 PDODD 57328 KC-FH US GOV'T • COMPRESSOR, RECIPROCATING ..................................... 1

Figure 3. Intake Filter Assembly

GROUP 01 RECIPROCATING COMPRESSOR

FIGURE 3 INTAKE FILTER ASSEMBLY

1 XDOZZ 57328 013758 • AIR CLEANER, INTAKE .................................................... 1

Figure 4. Cooling System (Sheet 1 of 3)

Figure 4. Cooling System (Sheet 2 of 3)

Figure 4. Cooling System (Sheet 3 of 3)

GROUP 01 RECIPROCATING COMPRESSOR

FIGURE 4 COOLING SYSTEM

1 XDOZZ 57328 014624 • COOLER, FLUID, INDUSTRIAL ....................................... 1

Figure 5. Oil Lubricating System

GROUP 01 RECIPROCATING COMPRESSOR

FIGURE 5 OIL LUBRICATING SYSTEM

1 PAOZZ 57328 TIE-0008 • STRAP, TIEDOWN, ELECTRICAL ................................... 1

Figure 6. 1st Stage Valve Head Assembly

GROUP 01 RECIPROCATING COMPRESSOR

FIGURE 6 1ST STAGE VALVE HEAD ASSEMBLY