CAT Engine Diagram P94-1298 C 01

8 CONNECTTOR CIRCUIT POSITION CHART

19 CONNECTOR CIRCUIT POSITION CHART
15 CONNECTOR CIRCUIT POSITION CHART
TERM INFORMATION FOR: 10 CONNECTOR CIRCUIT POSITION CHART
A F 13 1
K333-549-206 (J65)
4 TERM INFORMATION FOR: TERM INFORMATION FOR:
B E WIRE NUMBERCIRCUIT TERM
1 3 P20-1095 (J86) P20-1038 (J08)
C 2 WIRE NUMBERCIRCUIT TERM 87 65 WIRE NUMBERCIRCUIT TERM
D
WIRE0071 E139CT F 5 6 WIRE0038 P82KS 4 WIRE0174 C19SR_2 8
WIRE0072 E140CT D WIRE0040 P113KS 3 WIRE0335 G26SU 1
MATING VIEW WIRE0073 E141CT E MATING VIEW WIRE0580 P51KS 1 WIRE0344 GND_H 2
WIRE0121 E69CM1 A WIRE0603 C19SR 2 12 34 WIRE0320 C19SR 7
WIRE0195 E31CT C WIRE0327 E150SP 5
WIRE0292 L13LI B MATING VIEW WIRE0328 E150SU 6 70 58 GENERAL NOTES:
MATING VIEW TERM INFORMATION FOR:
16 CONNECTOR CIRCUIT POSITION CHART 1) USE ON BI, BII, BIII CABS FOR CAT C10/C12 OR
TERM INFORMATION FOR: TERM INFORMATION FOR: K333-616 (J02)
TERM INFORMATION FOR: P20-1038 (J60) C15/C16 ELECTRONIC ENGINES W/ ADEM III CONTROLLER.
K333-549-206 (J74) WIRE NUMBER CIRCUIT TERM
WIRE NUMBERCIRCUIT TERM P20-1071-01 (J80) WIRE NUMBERCIRCUIT TERM
40 35 WIRE0001 E69CM 5 2) HOW TO USE THIS DIAGRAM:
WIRE0079 E96ER F WIRE NUMBERCIRCUIT TERM WIRE0553 E150SU 6 EACH CONNECTOR HAS A DISTINCT ALPHANUMERIC
WIRE0018 E127CT 4
WIRE0080 E98ER E WIRE0068 E96ER 30 WIRE0554 E150SP 5 "REFERENCE DESIGNATOR" OR "REF_DES" PRINTED
WIRE0020 C144EF 11 NEXT TO IT. USE THE REF_DES TO FIND CONNECTOR
WIRE0084 P18WL B WIRE0069 E98ER 31 WIRE0560 C19SR 7 WIRE0024 E139CT 59 INFORMATION IN THE CONNECTOR INFORMATION TABLE.
WIRE0085 L95ER C WIRE0070 E95ER 32 WIRE0562 C19SR_2 8 WIRE0025 E141CT 44
WIRE0096 E95ER D WIRE0071 E139CT 12 WIRE0599 GND_H 2 WIRE0026 E140CT 35
WIRE0072 E140CT 16 WIRE0600 G26SU 1 3) DENOTES "TWISTED PAIR" OF WIRES.
WIRE0027 E96ER 23
6 1 WIRE0073 E141CT 20
WIRE0028 E98ER 40
WIRE0112 E127CT 13
WIRE0064 E205LC_1 54
WIRE0114 E128CT 17
20 CONNECTOR CIRCUIT POSITION CHART MATING VIEW 11 CONNECTOR CIRCUIT POSITION CHART WIRE0066 E207LC 2 4) DENOTES CABLE WITH TWISTED PAIR
WIRE0116 E129CT 21 AND SHIELDED.
2 WIRE0135 P118SD 70
3 1 WIRE0120 E69CM 35
TERM INFORMATION FOR: WIRE0156 E144CT 41

1
WIRE0124 S314AX 26
P20-1039 (P75) WIRE0163 G150SP 36
TERM INFORMATION FOR: WIRE0126 S306AX 7 X
1 4 WIRE NUMBERCIRCUIT TERM WIRE0164 G150SU 37 5) DESIGNATES REF POINTS ON ANOTHER SHEET.
K333-198 (J66) WIRE0128 S308AX 19
WIRE0551 E150SP 5 WIRE0205 GND_M 65
4 6 WIRE NUMBERCIRCUIT TERM WIRE0129 S310AX 23
5 WIRE0552 E150SU 6 WIRE0223 G881 62
WIRE0194 L13LI 4 WIRE0130 S312AX 22 6 CONNECTOR CIRCUIT POSITION CHART
WIRE0555 GND_H 2 WIRE0242 GND_M 67
MATING VIEW WIRE0139 G148SU 5 WIRE0131 S316AX 25
WIRE0556 G026SU 1 WIRE0286 E128CT 66
WIRE0140 G148TC 2 WIRE0133 S320AX 6 8 5
WIRE0559 C19SR 7 WIRE0287 E32SW 45
WIRE0139 G148SU 34 40 6 TERM INFORMATION FOR:
WIRE0561 C19SR_2 8 WIRE0288 E31CS 22
WIRE0140 G148TC 27 MATING VIEW WIRE0290 K999 56
P20-1070-01 (P01)
21 CONNECTOR CIRCUIT POSITION CHART WIRE0141 G150SU 28 WIRE NUMBERCIRCUIT TERM
WIRE0299 K982 60 WIRE0313 G148TC 27
5 6 WIRE0142 G150SP 24
TERM INFORMATION FOR: WIRE0303 G842 47 WIRE0314 G148SU 34
WIRE0150 C19SR 2
TERM INFORMATION FOR: P20-1039 (P76) WIRE0304 K998 30 WIRE0320 C19SR 2
K333-43 (J67) WIRE0154 L144EF 15
WIRE NUMBERCIRCUIT TERM WIRE0305 YEL 19 WIRE0330 C102FC 5
WIRE NUMBERCIRCUIT TERM WIRE0167 L58HW 40
WIRE0306 E108DB 8 WIRE0018 E127CT 13
WIRE0168 L58LO 39
WIRE0551 E150SP 5 WIRE0307 E109DB 9 WIRE0024 E139CT 12
1 2 3 4 WIRE0141 G150SU 2 WIRE0172 E32SW 9 35 1
WIRE0552 E150SU 6 WIRE0315 E158WL 28 WIRE0025 E141CT 20
WIRE0142 G150SP 3 WIRE0175 E31CS 8
WIRE0555 GND_H 2 WIRE0316 E159WL 29
MATING VIEW WIRE0391 L13LI 6 WIRE0176 S302AX 3
WIRE0556 G026SU 1 WIRE0319 RED 20
MATING VIEW WIRE0026 E140CT 16
WIRE0178 S304AX 4 WIRE0027 E96ER 30
WIRE0559 C19SR 7 WIRE0321 E144EF 46 WIRE0028 E98ER 31
WIRE0179 G25SU 36
WIRE0561 C19SR_2 8 WIRE0327 E150SP 32 WIRE0135 P118SD 1
22 CONNECTOR CIRCUIT POSITION CHART WIRE0180 E158WL 10
WIRE0328 E150SU 33 WIRE0161 L144EF 15
WIRE0181 E159WL 11
D C WIRE0340 E181CPB 52 WIRE0163 G150SP 24
WIRE0184 G57SU 38 12 CONNECTOR CIRCUIT POSITION CHART
TERM INFORMATION FOR: WIRE0342 E95ER 12 WIRE0164 G150SU 28
WIRE0185 G26SU 37
K333-586-206 (J62) WIRE0594 E205LC 26 WIRE0210 E69CM1 35
WIRE0186 E108DB 14 H
WIRE NUMBERCIRCUIT TERM A WIRE0597 E181CPB 53
WIRE0189 E109DB 18 TERM INFORMATION FOR: WIRE0212 E129CT 21
K333-549-208 (J83) WIRE0065 E206LC 49 WIRE0214 CSP2 3
WIRE0241 C23ES 33
WIRE0112 E127CT E WIRE NUMBERCIRCUIT TERM WIRE0228 E47SW 6 WIRE0215 CSP4 4
WIRE0591 C102FC 5
WIRE0114 E128CT C WIRE0193 L95ER G WIRE0237 E185DB 50 WIRE0286 E128CT 17
WIRE0579 E144EF 29
F A WIRE0116 E129CT D WIRE0165 L56LC A WIRE0238 E186DB 34 WIRE0287 E32SW 9
WIRE0588 P118SD 1 J
WIRE0122 E69CM A S WIRE0167 L58HW B WIRE0243 E23ES 13 WIRE0288 E31CS 8
MATING VIEW WIRE0123 E38SW F WIRE0289 993 3 WIRE0306 E108DB 14
WIRE0197 E37SW B 17 CONNECTOR CIRCUIT POSITION CHART MATING VIEW WIRE0293 K980 58 WIRE0307 E109DB 18
TERM INFORMATION FOR: WIRE0300 G845 68 WIRE0315 E158WL 10
F A TERM INFORMATION FOR: K333-549-208 (J98)
23 CONNECTOR CIRCUIT POSITION CHART WIRE0313 G148TC 38 WIRE0316 E159WL 11
K333-549-106 (P61) WIRE NUMBERCIRCUIT TERM WIRE0314 G148SU 39
E B WIRE0321 E144EF 29
WIRE NUMBERCIRCUIT TERM WIRE0595 CAN_SHLD_1 42
7 9 TERM INFORMATION FOR: WIRE0322 P18WL 7
16-07459 (J85) D C WIRE0039 L58LO G WIRE0609 GND_M 63
4 1 WIRE0325 L58HW 40
WIRE NUMBERCIRCUIT TERM WIRE0068 E96ER F WIRE0610 E181CPB 48 WIRE0334 G25SU 36
WIRE0069 E98ER E
WIRE0651 E144EF 3 MATING VIEW 13 CONNECTOR CIRCUIT POSITION CHART WIRE0335 G26SU 37
5B WIRE0652 E144EF 3 WIRE0070 E95ER D
2B WIRE0336 G57SU 38
WIRE0146 E69CM 2B WIRE0193 L95ER C 9 CONNECTOR CIRCUIT POSITION CHART
6 WIRE0338 L58LO 39
3 WIRE0202 P18WL B TERM INFORMATION FOR:
WIRE0155 L13LI 9 P20-1077 (P62) TERM INFORMATION FOR: WIRE0339 C23ES 33
8 WIRE0654 E69CM1 2B D K333-550-207 (J15)
10 WIRE NUMBERCIRCUIT TERM WIRE0341 L56LC 26
C
MATING VIEW TERM INFORMATION FOR:
E A B WIRE0611 P120DG B WIRE NUMBERCIRCUIT TERM
WIRE0342 E95ER 23
K333-549-106 (P51) F WIRE0188 E108DB F WIRE0289 993 A
WIRE NUMBERCIRCUIT TERM WIRE0191 E109DB G WIRE0293 K980 C
G D E
24 CONNECTOR CIRCUIT POSITION CHART WIRE0074 E69CM A J WIRE0294 E187DB E WIRE0300 G845 E 7 CONNECTOR CIRCUIT POSITION CHART
C A F
WIRE0086 E31CT C H WIRE0295 E185DB C WIRE0290 K999 B D
B G
TERM INFORMATION FOR: WIRE0088 E140CT D WIRE0299 K982 D TERM INFORMATION FOR:
K333-423(J99) WIRE0296 E186DB D K333-408 (J29)
WIRE0091 E141CT E WIRE0298 GND_B A WIRE0303 G842 F C
WIRE NUMBERCIRCUIT TERM WIRE NUMBERCIRCUIT TERM
7 8 9 10 11 12 WIRE0094 E139CT F WIRE0304 K998 G
1 2 3 4 5 6
WIRE0039 L58LO 4
WIRE0095 L13LI B MATING VIEW MATING VIEW WIRE0065 E206LC D
WIRE0046 L158WL 1 WIRE0064 E205LC_1 A
B
WIRE0048 L159WL 9 WIRE0066 E207LC C
MATING VIEW WIRE0042 L56LC 5 18 CONNECTOR CIRCUIT POSITION CHART 14 CONNECTOR CIRCUIT POSITION CHART A WIRE0067 E69CM B
WIRE0396 L58HW 8
WIRE0585 L144EF 2 10 TERM INFORMATION FOR: E H TERM INFORMATION FOR:
MATING VIEW
9 P20-1008 (J64) K333-549-108 (P63)
8 WIRE NUMBERCIRCUIT TERM WIRE NUMBERCIRCUIT TERM
7
25 CONNECTOR CIRCUIT POSITION CHART
6 5
WIRE0125 S314AX 6 WIRE0168 L58LO G
4 3
WIRE0126 S306AX 2 D
5 6 7 8
TERM INFORMATION FOR: 1 A
2 WIRE0127 E69CM1 1
1 2 3 4 K333-422 (J41) TERM INFORMATION FOR:
WIRE0128 S308AX 3
WIRE NUMBERCIRCUIT TERM
WIRE0129 S310AX 4
MATING VIEW K333-549-108 (P70)
WIRE0055 L95ER 6 MATING VIEW WIRE NUMBERCIRCUIT TERM
MATING VIEW WIRE0131 S316AX 7
WIRE0042 L56LC A
WIRE0133 S320AX 9
WIRE0396 L58HW B
WIRE0196 S312AX 5
WIRE0055 L95ER G
WIRE0203 P18WL 10
CAT Engine Diagram P94-1298 C 02

CONNECTOR INFORMATION FOR DIAGRAM:P94-1298

NUMBER OF PART
REF_DES DESCRIPTION LOCATION OF CONNECTOR
CAVITIES NUMBER
J01 2 K333-550-202 BLACK_PACKARD_280_SERIES TOP REAR LH CORNER OF ENGINE
J02 70 K333-616 AMP_70_WAY @ ENGINE ECU
J03 1 K333-236 BULLET_PLUGGED TOP FRONT LH SIDE OF ENGINE GENERAL NOTES: (continued from sheet 1
J04 1 K333-236 1-WAY_BULLET_PLUGGED TOP FRONT LH SIDE OF ENGINE
USE ON BI, BII, BIII CABS FOR CAT C10/C12 OR
J05 2 K333-25 MOLDED_2_WAY TOP REAR LH CORNER OF ENGINE C15/C16 ELECTRONIC ENGINES W/ ADEM III CONTROLLER.
J06 2 K333-550-202 BLACK_PACKARD_280_SERIES TOP FRONT LH SIDE OF ENGINE
J07 0 P67-1005-102-1 PLUG TOP FRONT LH SIDE OF ENGINE
26 CONNECTOR CIRCUIT POSITION CHART
J08 8 P20-1038 GRAY_DEUTSCH_DT_SERIES TOP REAR LH CORNER OF ENGINE 31 CONNECTOR CIRCUIT POSITION CHART
J09 3 P20-1073 BLACK_DEUTSCH_DT_J1939 TOP REAR LH CORNER OF ENGINE TERM INFORMATION FOR:
TERM INFORMATION FOR: B C
J10 3 P20-1075 BLACK_DEUTSCH_DT_J1939 LOWER LH SIDE OF ENGINE E K333-386 (J77)
D K333-562-108-1 (P21)
J11 3 P20-1073 BLACK_DEUTSCH_DT_J1939 ABOVE ENGINE ECU WIRE NUMBERCIRCUIT TERM
WIRE NUMBERCIRCUIT TERM
J12 1 K333-46-13 RING_TERMINAL @ STARTER SOLENOID
WIRE0535 C144EF F A D
J13 2 K333-505 GREY_2WAY_DEUTSCH_CONNECTOR NEAR ENGINE ECU WIRE0075 E69CM B
WIRE0537 C102FCA C
J14 3 K333-553 BLACK_PACKARD_150_SERIES NEAR ENGINE ECU WIRE0086 E31CT D
WIRE0539 C102FC E
J15 7 K333-550-207 BLACK_PACKARD_280_SERIES @ ENGINE ECU
WIRE0541 P144EF D MATING VIEW WIRE0090 E140CT A
J18 1 K333-46-7 RING_TERMINAL_(3/8") NEAR STARTER H A WIRE0093 E141CT C
WIRE0549 E208LC A
J19 1 K183-154-201 PLUG_BLACK_PACKARD_METRI-PACK TOP REAR LH CORNER OF ENGINE
J20 8 K333-562-208-1 BLACK_PACKARD_METRI-PACK_150_SEALED TOP FRONT LH SIDE OF ENGINE
MATING VIEW WIRE0550 E205LC B
27 CONNECTOR CIRCUIT POSITION CHART
J21 2 K333-390 BLACK_PACKARD_WEATHER_PACK TOP REAR LH SIDE OF ENGINE
TERM INFORMATION FOR:
J23 1 K333-46-26 RING_TERMINAL_1/4" @ FRAME GROUND K333-562-208-1 (J20)
F G
J24 1 K333-46-21 RING_TERMINAL_1/4" @ STARTER GROUND E WIRE NUMBERCIRCUIT TERM
32 20A FUSE & CKT E181CP1 ARE NOT USED. H
J25 1 K333-46-25 RING_TERMINAL_3/8" @ ENGINE GROUND WIRE0211 E69CM2 D
J26 1 K333-46-19 RING_TERMINAL_5/16" TOP REAR LH CORNER OF ENGINE 33) SUPERSEDED BY P94-1515 PROD X
WIRE0225 C102FCA F
SERV
J27 1 K333-36 MOLDED_90_DEGREE TOP FRONT LH SIDE OF ENGINE WIRE0156 E144CT E
J28 1 K333-550-201 BLACK_PACKARD_METRI_PACK NEAR ENGINE ECU A
D C B WIRE0330 C102FC C
J29 4 K333-408 BLACK_PACKARD_WEATHER_PACK TOP FRONT LH SIDE OF ENGINE WIRE0593 E69CM2 A
J30 1 K333-40 MOLDED_90_DEGREE TOP FRONT LH SIDE OF ENGINE CONNECTOR INFORMATION FOR DIAGRAM:P94-1298 MATING VIEW WIRE0594 E205LC B
J31 1 K333-50-14 90_DEGREE_BULLET TOP FRONT LH SIDE OF ENGINE
NUMBER OF PART
J32 2 K333-550-202 BLACK_PACKARD_280_SERIES NEAR CENTER OF FIREWALL REF_DES DESCRIPTION LOCATION OF CONNECTOR
CAVITIES NUMBER 28 CONNECTOR CIRCUIT POSITION CHART
J33 1 K333-36 MOLDED_90_DEGREE TOP FRONT LH SIDE OF ENGINE J98 8 K333-549-208 BLACK_PACKARD_METRI-PACK BEHIND ENGINE GAUGE CLUSTER
J34 2 K333-550-202 BLACK_PACKARD_280_SERIES TOP REAR LH CORNER OF ENGINE J99 12 K333-423 NATURAL_12-WAY_MOLEX_CONNECTOR LOCATED IN HEADER, @WARN LP MODULE B3 A2
J35 2 K333-550-202 BLACK_PACKARD_280_SERIES TOP REAR LH CORNER OF ENGINE J100 6 K333-550-206 BLACK_PACKARD_METRI-PACK_280_SERIES NEAR BATTERY BOX A3
J36 2 K333-550-202 BLACK_PACKARD_280_SERIES LOCATED NEAR ENGINE ECU P01 40 P20-1070-01 BROWN_YAZAKI_40_WAY CENTER OF FIREWALL
C3
C2
J37 9 P20-1074 GRAY_DEUTSCH_DT_J1939 BEHIND GAUGE PANEL IN DASH P03 2 P20-1158-102 GRY_DEUTSCH_DTP NEAR ENGINE ECU C1
J38 3 P20-1073 BLACK_DEUTSCH_DT_J1939 BEHIND GAUGE PANEL IN DASH P04 3 K183-150-1 PLUG_BLACK_PACKARD_150_SERIES NEAR ENGINE ECU B1
J39 3 P20-1073 BLACK_DEUTSCH_DT_J1939 BEHIND GAUGE PANEL IN DASH A1 B2
P05 7 K183-154-107 PLUG_BLACK_PACKARD_280 ABOVE ENGINE ECU
J40 3 P20-1073 BLACK_DEUTSCH_DT_J1939 BEHIND LH GAUGE PANEL P07 3 P20-1072 BLACK_DEUTSCH_DT_J1939 ABOVE ENGINE ECU
J41 8 K333-422 NATURAL_8-WAY_MOLEX_CONNECTOR LOCATED IN HEADER, @WARN LP MODULE
MATING VIEW
P08 1 K333-550-101 BLACK_PACKARD_METRI-PACK_280_SEALED TOP REAR LH CORNER OF ENGINE
J42 3 P20-1073 BLACK_DEUTSCH_DT_J1939 NEAR TRANSMISSION (LH SIDE) P09 1 K333-550-101 BLACK_PACKARD_METRI-PACK NEAR ENGINE ECU
J43 9 P20-1074 GRAY_DEUTSCH_DT_J1939 NEAR TRANSMISSION (LH SIDE) 29 CONNECTOR CIRCUIT POSITION CHART
P10 2 K183-154-102 PLUG_BLACK_PACKARD_METRI-PACK TOP REAR LH CORNER OF ENGINE
J44 9 P20-1074 GRAY_DEUTSCH_DT_J1939 BEHIND LH GAUGE PANEL P13 4 K333-409 BLACK_PACKARD_WEATHER_PACK TOP FRONT LH SIDE OF ENGINE
J45 3 P20-1075 BLACK_DEUTSCH_DT_J1939 BEHIND LH GAUGE PANEL C TOP D TERM INFORMATION FOR:
P14 1 K333-537-2 BLACK_1-WAY_DEUTSCH_DT NEAR ENGINE ECU K333-27 (J50)
J47 1 K333-41 BULLET BEHIND ENGINE GAUGE CLUSTER P15 2 P20-1040 BLACK_METRI-PACK_150-SERIES TOP REAR LH CORNER OF ENGINE WIRE NUMBERCIRCUIT TERM
J48 1 K333-598 BLACK_ELECTRO-WIRE_1-WAY LH SIDE OF DASH, AREA #1 P16 1 K333-549-101 BLACK_PACKARD_280_M/P LOCATED BEHIND SWITCH PANEL, AREA#5 WIRE0081 E97ER F
J49 1 K333-598 BLACK_ELECTRO-WIRE_1-WAY LH SIDE OF DASH, AREA #1 P21 8 K333-556-108-1 BLACK_PACKARD_METRI-PACK_150_SEALED TOP FRONT LH SIDE OF ENGINE B E WIRE0102 L95ER A
J50 6 K333-27 BLACK_PACKARD_56_SERIES LOCATED BEHIND SWITCH PANEL, AREA#5 P33 2 K183-154-102 PLUG_BLACK_PACKARD_METRI-PACK TOP REAR LH CORNER OF ENGINE WIRE0105 E69CM E
J51 6 K333-27 BLACK_PACKARD_56_SERIES LOCATED BEHIND SWITCH PANEL, AREA#5 P34 2 K183-154-102 PLUG_BLACK_PACKARD_METRI-PACK TOP REAR LH CORNER OF ENGINE WIRE0109 P18WL B
J52 2 K333-549-202 BLACK_PACKARD_METRI-PACK_280_UNSEALEDLOCATED BEHIND SWITCH PANEL, AREA#5 P36 3 P20-1072 BLACK_DEUTSCH_DT_J1939 LOCATED LH SIDE DASH NEAR PASS THRU A F
J53 6 K333-27 WHITE_PACKARD_56_SERIES LOCATED BEHIND SWITCH PANEL, AREA#5 P39 2 K333-550-102 BLACK_PACKARD_280_SERIES RH FRONT SIDE OF ENGINE TERM INFORMATION FOR:
J54 6 K333-27 WHITE_PACKARD_56_SERIES LOCATED BEHIND SWITCH PANEL, AREA#5
MATING VIEW K333-27 (J51)
P46 3 P20-1076 GRAY_DEUTSCH_DT BEHIND GAUGE PANEL IN DASH
J55 1 P20-1112 BLACK_AMP_1/4"_RECEPTACLE BEHIND SERVICE BRAKE SW P51 6 K333-549-106 BLACK_PACKARD_METRI-PACK_280_UNSEALEDLOCATED BEHIND SWITCH PANEL, AREA#5 WIRE NUMBERCIRCUIT TERM
J56 1 P20-1112 BLACK_AMP_1/4"_RECEPTACLE BEHIND SERVICE BRAKE SW P52 1 P20-1014 BLACK_PACKARD_METRI-PACK_150_UNSEALEDLOCATED BEHIND SWITCH PANEL, AREA#5
J57 1 K333-598 BLACK_ELECTRO-WIRE_1-WAY LH SIDE OF DASH, AREA #1 P56 1 K333-549-101 BLACK_PACKARD_METRI-PACK_UNSEALED BEHIND SWITCH PANEL WIRE0076 E69CM B
J58 1 P20-1112 BLACK_AMP_1/4"_RECEPTACLE LH SIDE OF DASH, AREA #1 P57 1 K333-549-101 BLACK_PACKARD_METRI-PACK_UNSEALED BEHIND SWITCH PANEL WIRE0094 E139CT A
J59 1 P20-1112 BLACK_AMP_1/4"_RECEPTACLE BEHIND SWITCH PANEL P59 6 K333-586-106 GRAY_PACKARD_METRI-PACK_150_SERIES_UNSEALED
BEHIND SPEEDO/TACH PANEL
J60 8 P20-1038 GRAY_DEUTSCH_DT_SERIES LOCATED NEAR TRANSMISSION P60 10 P20-1048 BLACK_AMP_UNSEALED LOCATED BEHIND SWITCH PANEL, AREA#5 TERM INFORMATION FOR:
J61 1 K333-113 1-WAY_BULLET LOCATED NEAR TRANSMISSION K333-27 (J53)
P61 6 K333-549-106 BLACK_PACKARD_METRI-PACK_280_UNSEALEDLOCATED BEHIND SWITCH PANEL, AREA#5
J62 6 K333-586-206 GRAY_PACKARD_METRI-PACK_150_SERIES_UNSEALED
BEHIND SPEEDO/TACH PANEL WIRE NUMBERCIRCUIT TERM
P62 9 P20-1077 BLACK_DEUTSCH_HDI0 LH SIDE OF DRIVER UNDER DASH
J63 3 K333-398 BLACK_PACKARD_WEATHER_PACK_SEALED NEAR THROTTLE PEDAL P63 8 K333-549-108 BLACK_PACKARD_METRI-PACK_280_UNSEALEDBEHIND ENGINE GAUGE CLUSTER
J64 10 P20-1008 BLACK_AMP_UNSEALED LOCATED BEHIND SWITCH PANEL, AREA#5 WIRE0082 E97ER B
P64 1 K333-549-101 BLACK_PACKARD_METRI-PACK_UNSEALED LOCATED BEHIND SWITCH PANEL, AREA#5
J65 6 K333-549-206 BLACK_PACKARD_METRI-PACK_280_UNSEALEDLOCATED BEHIND SWITCH PANEL, AREA#5 WIRE0083 E97ER E
P65 1 K333-549-101 BLACK_PACKARD_METRI-PACK_UNSEALED LOCATED BEHIND SWITCH PANEL, AREA#5
J66 6 K333-198 BLACK_PACKARD_56-SERIES BEHIND SPEEDO/TACH PANEL WIRE0097 E96ER F
P66 3 K333-387 BLACK_PACKARD_WEATHER_PACK_SEALED NEAR THROTTLE PEDAL
J67 6 K333-43 BLACK_PACKARD_56-SERIES BEHIND SPEEDO/TACH PANEL WIRE0101 E98ER A
P68 3 K333-385 BLACK_PACKARD_METRI-PACK @ BATTERY BOX
J68 1 P20-1112 BLACK_AMP_1/4"_RECEPTACLE BEHIND SPEEDO/TACH PANEL P69 3 K333-372 BLACK_PACKARD_150 BEHIND ENGINE GAUGE CLUSTER TERM INFORMATION FOR:
J69 1 P20-1112 BLACK_AMP_1/4"_RECEPTACLE BEHIND SPEEDO/TACH PANEL P70 8 K333-549-108 BLACK_PACKARD_METRI-PACK BEHIND ENGINE GAUGE CLUSTER K333-27 (J54)
J70 1 K333-549-201 BLACK_PACKARD_METRI-PACK_280_UNSEALEDLOCATED BEHIND SWITCH PANEL, AREA#5 P73 2 K333-550-102 BLACK_PACKARD_280_SERIES NEAR CENTER OF FIREWALL WIRE NUMBERCIRCUIT TERM
J74 6 K333-549-206 BLACK_PACKARD_METRI-PACK_280_UNSEALEDLOCATED BEHIND SWITCH PANEL, AREA#5 P75 8 P20-1039 GRAY_DEUTSCH_DT_SEALED TOP REAR LH CORNER OF ENGINE
J75 2 K333-550-202 RED_PACKARD_METRI-PACK_150_SEALED @ A/C BINARY SWITCH P76 8 P20-1039 GRAY_DEUTSCH_DT_SEALED LOCATED NEAR TRANSMISSION WIRE0087 E69CM B
J76 2 K333-549-202 BLACK_PACKARD_METRI-PACK_280_UNSEALEDLOCATED BEHIND SWITCH PANEL, AREA#5 P77 1 K333-126 1-WAY_BULLET LOCATED NEAR TRANSMISSION WIRE0089 E140CT A
J77 4 K333-386 BLACK_PACKARD_WEATHER_PACK NEAR SWITCH PANEL, AREA #5 WIRE0092 E141CT C
J78 2 K333-550-202 BLACK_PACKARD_METRI-PACK_280_SEALED RH FRONT SIDE OF ENGINE
J79 1 K333-237 BLACK_MOLDED_1-WAY BEHIND ENGINE GAUGE CLUSTER
J80 40 P20-1071-01 BROWN_YAZAKI_UNSEALED LOCATED@ CENTER OF FIREWALL 30 CONNECTOR CIRCUIT POSITION CHART
J81 1 K333-46-19 RING_TERMINAL @ FIREWALL GROUND
J82 1 K333-36 BLACK_MOLDED_1-WAY_90DEG BEHIND DASH PANEL, AREA #2 F A TERM INFORMATION FOR:
K333-586-106 (P59)
J83 8 K333-549-208 BLACK_PACKARD_METRI-PACK_280_UNSEALEDBEHIND ENGINE GAUGE CLUSTER B
WIRE NUMBERCIRCUIT TERM
J84 1 K333-36 BLACK_MOLDED_1-WAY_90DEG BEHIND DASH PANEL, AREA #2
WIRE0113 E127CT E
J85 10 16-07459 CONNECTOR-SWITCH LH SIDE OF DASH, AREA #1 E C
D WIRE0115 E128CT C
J86 6 P20-1095 6_WAY_56_SERIES @ KEY SWITCH
WIRE0117 E129CT D
J87 3 P20-1075 BLACK_DEUTSCH_DT_J1939 NEAR TRANSMISSION (LH SIDE)
MATING VIEW
J88 1 K333-36 BLACK_MOLDED_1-WAY_90DEG BEHIND DASH PANEL, AREA #2
J89 3 K333-371 BLACK_PACKARD_150 BEHIND ENGINE GAUGE CLUSTER
J90 1 K333-549-201 BLACK_PACKARD_METRI-PACK_UNSEALED BEHIND SWITCH PANEL
J91 2 P20-1078 BLACK_PACKARD_METRI-PACK_150_UNSEALEDBEHIND LH GAUGE PANEL
J92 2 K333-562-202-1 LT_GRAY_PACKARD_METRI-PACK_150_SEALED NEAR SURGE TANK
J93 1 P20-1112 BLACK_AMP_1/4"_RECEPTACLE NEAR SWITCH PANEL HARNESS
J94 1 P20-1015 BLACK_PACKARD_METRI-PACK_150_UNSEALEDLOCATED BEHIND SWITCH PANEL, AREA#5
J96 2 P20-1158-202 GRAY_DEUTSCH_DTP REAR FACE OF FLYWHEEL HOUSING, LH SIDE
J97 3 K333-388 BLACK PACKARD METRI-PACK 630 SEALED @ BATTERY BOX
CAT Engine Diagram P94-1298 C 03
A CONTINUED ON TO INSTRUMENT
SHT 4, ZONE A14
PANEL HARNESS
6
3 4 36 37 38 11 10 15 2 39 40 18 14 30 31 32 5 1 12 16 20 8 7 19 23 22 26 25 33 6 9 21 17 13 35 29 24 28 27 34
P33 J35 P01

G26SU VIO WIRE0335

C102FC L_GRN/WHT WIRE0330

WIRE0336
G25SU PNK WIRE0334

L144EFWHT/L_GRNWIRE0161

L58LO GRN/BRN WIRE0338

SPARE_CSP2

E158WLBRN/ORNWIRE0315

P118SD RED/GRN WIRE0135

E96ER LT_GRN/YEL WIRE0027

E98ER LT_GRN/BLK WIRE0028

B CSP2 RED WIRE0214

L58HW GRN/BRN WIRE0325

L56LC L_GRN/BLU WIRE0341

E139CT ORN/BRN WIRE0024

E140CT ORN/RED WIRE0026

E141CT ORN/GRN WIRE0025

E159WLBRN/WHTWIRE0316

E95ER BLK/L_GRN WIRE0342

E31CS YEL/PUR WIRE0288

P18WL L_GRN WIRE0322

C19SR TAN WIRE0320
P34 J34 A GND_RWHT WIRE0216

PUR/YEL
01 C23ES TAN/GRN WIRE0339 F1

E109DBBLU/L_BLUWIRE0307

E108DBBLU/BLKWIRE0306
A GND_RWHT WIRE0217 ETHER START

G148TC BLK/RED WIRE0313

E128CT BRN/RED WIRE0286
M1 SOLENOID
USAGE NOTE:

E127CT BRN/GRA WIRE0018

SPARE_CSP4 C23HS TAN/GRN WIRE0324

E129CT BRN/GRN WIRE0212

G150SP BLU/RED WIRE0163

G150SU BLU/RED WIRE0164

G148SU BLK/RED WIRE0314

E144EF WHT/LTGRN WIRE0321
E32SW YEL/GRN WIRE0287
B

G57SU
CSP4 RED WIRE0215

E69CM1 GRA WIRE0210

J05 USE ON BI, BII, BIII CABS FOR CAT C10/C12
J03 ETHER OR C15/C16 ENGINES W/ ADEM III CONTROLLER.
WATER TEMP START
SENSOR (GAUGE) G57SU PUR/YEL WIRE0336 THERMO
J33 SWITCH
CONTINUED ON B
SHT 5, ZONE K7 TO J1939 DATA LINK
A L144EF WHT/L_GRN WIRE0161 PASS THRU HARNESS
TO ENGINE
FAN ON PRESS B P18WL L_GRN WIRE0322 J27 S3 F
SWITCH A B C
J32 L58LO GRN/BRN WIRE0338 ENGINE OIL J09 SEE DETAIL "A"
WATER J04 PRESSURE SW SHT 6, ZONE G15
TEMP L58HW
GRN/BRN
WIRE0325 (WARNING) FOR CONTINUATION
SWITCH LOW COOLANT

CAN_SHLD_2WHT WIRE0005
CAN_H YEL WIRE0235
(WARN) J31 PROBE

CAN_L GRN WIRE0337

C H
1

CONTINUED C
ON SHT 5, C102FC L_GRN/WHT WIRE0330
10
ZONE J6 D E69CM2 GRA WIRE0211
A E69CM2 GRA WIRE0593

TO COOLING G
MODULE
HARNESS E E144CT WHT/LT_GRN WIRE0156
12
F C102FCA
L_GRN/WHT
WIRE0225 G26SU VIO WIRE0335
GND_RWHT WIRE0218

11
B E205LC BLU/BLK WIRE0594 E185DB YEL WIRE0237
15
27 J20 E186DB GRN WIRE0238
1

AC COMPRESOR A GND_HWHT WIRE0220

CAN_SHLDBARE WIRE0596
CLUTCH 10

CAN_L GRN WIRE0234

J08

CAN_SHLDBARE WIRE0236
J06 GND_DWHT WIRE0157
1 D
WATER 02 G26SU VIO WIRE0335
TEMP GND_HWHT WIRE0332
3 CONTINUED ON
SENSOR
SHT 6, ZONE E14
(GAUGE) J30
GND_HWHTWIRE0344 GND_HWHT WIRE0344 2
GND_GWHT WIRE0208

ENGINE FAN A GND_HWHT WIRE0331 4 TO

SOLENOID C S2 CAT CHASSIS
B C144EF
WHT/LTGRN
WIRE0020 E150SP BLU/RED WIRE0327 5 HARNESS
J21 E150SU BLU/RED WIRE0328 6

FIREWALL C19SR TAN WIRE0320 7

J28
GROUND GND_CWHTWIRE0209

CAN_H YEL WIRE0233

C19SR_2 TAN WIRE0174 8 09 08
J26 05 CAN_SHLDBARE WIRE0232
GND_EWHT WIRE0349 STARTERP09

CAN_SHLD_2WHT WIRE0003

CAN_SHLD_1WHT WIRE0390
INTERRUPT J13
ENGINE
GND_AWHT WIRE0345 GND_BWHT WIRE0206
GROUND 2
C19SR_1 TAN WIRE0329 TO
J25 BATTERY BOX
GND_EWHT WIRE0349 1 EXT HARNESS
STARTER
GROUND GND_J WHT WIRE0201 P14
SEE CHARGE&
J24 START DIAG
9 1

FRAME TO MULTI-FUNCTION INPUT J12

TO J18
GROUND GND_KWHT WIRE0347 FOR REMOTE PTO& THROTTLE
P05 C17SR ORN WIRE0350 STARTER ENGINE 1
J23 A E C D B F G SOLENOID P07
GROUND
P15 A B C
A E C D B F G S
J15 GND_HWHT WIRE0244 A TO A B C
ETHER J87 CONTINUED ON
E23ES TAN/GRN WIRE0243 B START SHT 6, ZONE J9
E69CM GRA WIRE0151

B1

E185DB YEL WIRE0237

E186DB GRN WIRE0238

J07 SAE J1939 DATA LINK
ENGINE OIL A A GND_HWHT WIRE0333 J14 TERMINATION RESISTOR,
TEMP SENSOR SEE DETAIL "B" SHT 6
B B G25SU PNK WIRE0334 GND_DWHT WIRE0157 B B
TO TOP-2
E109DB BLU/L_BLU WIRE0307

J36 YEL WIRE0305 A A TRANSMISSION

E108DB BLU/BLK WIRE0306

2-SPEED AXLE OPTIONAL

PRESS SW SHOWN 2-SPEED REAR RED WIRE0319 C C

G150SP BLU/RED WIRE0163

G150SU BLU/RED WIRE0164

G148TC BLK/RED WIRE0313

G148SU BLK/RED WIRE0314

E150SP BLU/RED WIRE0327

E150SU BLU/RED WIRE0328

IN LOW SPEED RANGE AXLE WIRING
G845 PUR WIRE0300
993 BRN WIRE0289

P10 J01 P04

S1
E98ER LT_GRN/BLK WIRE0028

B E47SW YEL/BLU WIRE0228 CONTINUED ON

E140CT ORN/RED WIRE0026

E141CT ORN/GRN WIRE0025

P03 G
E31CS YEL/PUR WIRE0288

06 13 14 SHT 6, ZONE B11

A E69CM GRA WIRE0226 1
E181CPA RED WIRE0192 1
TO
E139CT ORN/BRN WIRE0024

2 POWER FUSE
INPUT #7 FNA OVERRIDE SWE144EF WHT/LTGRN WIRE0321
E96ER LT_GRN/YEL WIRE0027
E144CT WHT/LT_GRN WIRE0156

E47SW YEL/BLU WIRE0228

E23ES TAN/GRN WIRE0243

P118SD RED/GRN WIRE0135

C144EF WHT/LTGRN WIRE0020

E159WL BRN/WHT WIRE0316

07 HARNESS
+8V (THROTTLE POS SENS) E127CT BRN/GRA WIRE0018
E128CT BRN/RED WIRE0286

E95ER BLK/L_GRN WIRE0342

E32SW YEL/GRN WIRE0287

K980 PNK WIRE0293

K982 YEL WIRE0299

K999 GRN WIRE0290

G842 GRY WIRE0303

K998 BLU WIRE0304

P08

E181CPB RED WIRE0610

E181CPB RED WIRE0340

E181CPB RED WIRE0597

DATA LIN (J1939 SHLD)CAN_SHLD_1WHT WIRE0595
TO CAT OVERSPEED

GND_MWHT WIRE0205

GND_MWHT WIRE0609
G881 BLU WIRE0223

GND_MWHT WIRE0242
P13 ENGINE SHUTDOWN
E69CM GRA WIRE0001

B B B J19
E69CM GRA WIRE0563 E69CM GRA WIRE0067
COOLANT C E207LC BLU/RED WIRE0564 C C
E207LC BLU/RED WIRE0066
LEVEL
SENSOR D E206LC BLU/WHT WIRE0565 D D
E206LC BLU/WHT WIRE0065
A A A
E205LC BLU/BLK WIRE0566 E205LC_1 BLU/BLK WIRE0064
INPUT #8 (REMOTE THROTTLE)
THROTTLE SW SENSOR COMM

INPUT #3 (RMT PTO RESUME)

INPUT #5 (IGNORE BK/CL SW)

SERV BRAKE PEDAL POS SW

INPUT #2 (REMOTE PTO SET)

INPUT SENSOR COMMON #2
OUTPUT #5 (COOLING FAN)

INPUT #1 (PTO ON/OFF SW)

CRUISE CNTRL ON/OFF SW

J29 7
INPUT #11 (A/C PRESS SW)

OUTPUT #12 PARK BRAKE

OUTPUT #3 BRAKESAVER
RESUME (CRUISE CNTRL)

J02
COOLANT LEVEL NORM

OUTPUT #1 (PTO LAMP)

2 SPEED AXLE SWITCH
+5V (LOW COOL SENS)

COOLANT 26 54 49 2 5 41 11 6 23 40 29 9 8 59 35 44 22 45 66 12 4 3 68 58 60 56 47 30 1 14 46 36 37 38 39 28 32 33 13 50 34 42 70 19 20 65 67 63 10 48 52 53 62
COOLANT LEVEL LOW

UNSWITCHED + BATT

UNSWITCHED + BATT

UNSWITCHED + BATT
CLUTCH PED POS SW

VEHICLE SPEED IN +

8
SET (CRUISE CNTRL)
RET SOL LOW/HI SW

RET SOL MED/HI SW

VEHICLE SPEED IN -
DATA LINK (J1922 +)

DATA LINK (J1939 +)

LEVEL
DATA LINK (J1922 -)

DATA LINK (J1939 -)

DATA LINK/J1587+

IGNITION KEY SW
SPEEDOMETER +
DATA LINK/J1587-

HARNESS
SPEEDOMETER -
COOLANT LEVEL

ETHER START
WARNING LAMP

TACHOMETER +

TACHOMETER -
ACC PED POS

OPTIONAL 4-WIRE ELECTRONIC

OUTPUT #2

OUTPUT #6

OUTPUT #7

BATTERY -

BATTERY -

BATTERY -
LOW COOLANT CONTROL
SENSOR MODULE
CAT Engine Diagram P94-1298 C 04
DIAGNOSTIC DATA LINK F7-F12
(J1587/J1708 and J1939)

13 1
J H G F B D C E A

P18WL L_GRN WIRE0586

P18WL
P62
USAGE NOTE:

HARNESS DIAGRAM P120DG RED/BLU WIRE0611

J1587/J1708 39 40 04 P52AF
CONTINUED ON H DATA BLOCK B A GND_B WHT WIRE0298GND_CWHTWIRE0301 GND_TWHTWIRE0302 GND_J WHT WIRE0601 USE ON BI, BII, BIII CABS FOR CAT C10/C12 OR
J81
SHT 5, ZONE H11 J91 C15/C16 ELECTRONIC ENGINES W/ ADEM III CONTROLLER.

E108DB BLU/BLK WIRE0187

E109DB BLU/L_BLU WIRE0190
H

E186DB GRN WIRE0296

P79BL

E185DB YEL WIRE0295

_ E187DB WHT WIRE0294
E109DB BLU/L_BLU WIRE0191
G L95ER BLK/LTGRN WIRE0193 1

E108DB BLU/BLK WIRE0188

P118SD
F
FIREWALL
E GROUND
TO CAB
ROOF J70
HARNESS D
P118SD RED/GRN WIRE0588 P118SDA RED/GRN WIRE0612
C P61 17

SEE INSTR PANEL

P16
B L58HW GRN/BRN WIRE0167 E96ER LT_GRN/YEL WIRE0068 F

A L56LC LTGRN/BLU WIRE0165 E98ER LT_GRN/BLK WIRE0069 E

P46
TO SWITCH
12 J83 21 B A C J E95ER BLK/LT_GRN WIRE0070 D HARNESS
P63 20 CONTROL SEE DETAIL "A" L95ER BLK/LTGRN WIRE0193 C
14 DATA LINK SHT 6, ZONE K12 25
A (J1939) FOR CONTINUATION P18WL L_GRN WIRE0202 B
M CONTINUED ON
B A SHT 5, ZONE G8
TO CAB P18WL L_GRN WIRE0586
ROOF
HARNESS
L56LC
LTGRN/BLU
WIRE0165
G L58LO GRN/BRN WIRE0168 J65 19

K H L13LI GRY WIRE0292 B

CONTINUED ON
SHT 5, ZONE F11 E69CM1 GRY WIRE0121 A

E139CT ORN/BRN WIRE0071 F

TO SWITCH
HARNESS
E140CT ORN/RED WIRE0072 D

E141CT ORN/GRN WIRE0073 E

E31CT YEL/PUR WIRE0195 C N CONTINUED ON

SHT 5, ZONE C8
KEY J68

L56LC LTGRN/BLU WIRE0165

SWITCH
J69
3 CM CLUTCH
P113KS RED/BRN WIRE0040 18
SWITCH J64
5 (PEDAL CONTROL
IGN
SEE CHARGE& NO NC ADAPTER
START DIAGRAM RELEASED) E69CM1 GRY WIRE0127 1 1 INSTRU
BAT 4 P82KS ORN/RED WIRE0038 HARNESS
STR
S4 CONTROL PANEL
17 S306AX BLK/PUR WIRE0126 2 2 P18WL L_GRN WIRE0166 HARNESS HARNESS
2 C19SR TAN WIRE0603
ACC
S308AX BRN/BLU WIRE0128 3 3 J59 SEE BRAKESAVER
6 EXHAUST BRAKE
C19SR TAN WIRE0602

S310AX BRN/L_GRN WIRE0129 4 4 CSP10 BRN/L_GRN WIRE0239 CSP10 BRN/L_GRN WIRE0239 DIAGRAM FOR
1 P51KS RED/YEL WIRE0580 OPTIONAL WIRING
S312AX BRN/YEL WIRE0196 5 5
15 J86
S314AX L_BLU/ORN WIRE0125 6 6 L56LC LTGRN/BLU WIRE0240 L56LC LTGRN/BLU WIRE0240 A
CONTINUED ON
L SHT 5, ZONE E11 S316AX L_BLU/PUR WIRE0131 7 7 P56 J90
CAB ROOF 44
1 8 8 SEE ETHER START
HARNESS L144EF WHT/LT_GRN WIRE0183 C23ES TAN/GRN WIRE0241
DIAGRAM FOR
(WRN LP
J79 19 9 9 P57 OPTIONAL WIRING
MODULE) S320AX L_GRN/BRN WIRE0133

P18WL L_GRN WIRE0203 10 10 P18WL L_GRN WIRE0166

23
C L144EF WHT/LT_GRN WIRE0182 P60 J85
CAB 6
C19SR TAN WIRE0152

ROOF B E158WL BRN/ORN WIRE0180 36

HARNESS L13LI GRY WIRE0155 L13LI GRY WIRE0155 9
A E159WL BRN/WHT WIRE0181
L 4
J89
CONTINUED ON E69CM GRY WIRE0146 E69CM GRY WIRE0146 7
SHT 5, ZONE E11 41
E69CM GRY WIRE0173 E69CM GRY WIRE0173 10
ENG COOLANT ENGINE FAN
TEMP SENSOR E69CM GRY WIRE0122 8 AUTO/MANUAL
(GAUGE) 42 SWITCH
J88 43 E38SW YEL/RED WIRE0123 S5 5B
35
TMSN OIL E37SW BRN/BLK WIRE0197 J55 2B
TEMP SENSOR
(GAUGE) E32SW YEL/GRN WIRE0172 1
J82
SEE HVAC DIAGRAM

J56 3
SERVICE BRAKE

E144EF WHT/LT_GRN WIRE0651

ENGINE OIL PRESSURE SWITCH
TEMP SENSOR
(GAUGE) J48
J84

E69CM1 GRY WIRE0654

E144EF WHT/LT_GRN WIRE0579 A A E144EF WHT/LT_GRN WIRE0652
P64 J49
E109DB BLU/L_BLU WIRE0189

SPARE
ENGINE
E108DB BLU/BLK WIRE0186

G150SP BLU/RED WIRE0142

G150SU BLU/RED WIRE0141

G150SU BLU/RED WIRE0141

G150SP BLU/RED WIRE0142

CIRCUITS P65
S320AX L_GRN/BRN WIRE0133
S316AX L_BLU/PUR WIRE0131
L144EF WHT/LT_GRN WIRE0154

S310AX BRN/L_GRN WIRE0129

J57
E144EF WHT/LT_GRN WIRE0579
S314AX L_BLU/ORN WIRE0124
G57SU PUR/YEL WIRE0184

E96ER LT_GRN/YEL WIRE0068

E95ER BLK/LT_GRN WIRE0070

E98ER LT_GRN/BLK WIRE0069
E159WL BRN/WHT WIRE0181

E158WL BRN/ORN WIRE0180

L13LI GRY WIRE0391

J58
S308AX BRN/BLU WIRE0128

E32SW YEL/GRN WIRE0172

S306AX BLK/PUR WIRE0126
C102FC L_GRN/WHT WIRE0591

A
S304AX BLK/GRN WIRE0178

E31CS YEL/PUR WIRE0175

L58LO GRN/BRN WIRE0168

P118SD RED/GRN WIRE0588

S312AX BRN/YEL WIRE0130

E141CT ORN/GRN WIRE0073
E140CT ORN/RED WIRE0072
G25SU PINK WIRE0179

E139CT ORN/BRN WIRE0071

C23ES TAN/GRN WIRE0241

G26SU VIO WIRE0185

E129CT BRN/GRN WIRE0116

S302AXBLK/YELWIRE0176

E128CT BRN/RED WIRE0114

G148TC BLK/RED WIRE0140

E127CT BRN/GRY WIRE0112

G148SU BLK/RED WIRE0139

L58HW GRN/BRN WIRE0167

SPARE
C19SR TAN WIRE0150

J62 22 ENG FAN

L13LI GRY WIRE0194

SW (OPT)
E69CM GRY WIRE0120

E38SW YEL/RED WIRE0123 F

E69CM GRY WIRE0122 A

TO
E37SW BRN/BLK WIRE0197 B THROTTLE
PEDAL EXT
E129CT BRN/GRN WIRE0116 D HARNESS

E128CT BRN/RED WIRE0114 C

J66 J67
16 J80
3 4 36 37 38 11 10 15 2 39 40 18 14 30 31 32 1 5 12 16 20 8 7 19 23 22 26 25 33 6 9 21 17 13 35 29 24 28 27 34 6 5 2 3 4 1 6 2 3 4 5 1 E127CT BRN/GRY WIRE0112 E P

A CONTINUED ON TACHOMETER SPEEDOMETER 21 CONTINUED ON

TO 20 SHT 5, ZONE C15
SHT 3, ZONE L13
ENGINE
HANRESS
 CAT Engine Diagram P94-1298 C 05

P73
H1 ENGINE
FAN "ON" S6
LOW COOLANT LOW OIL HIGH WATER CHECK STOP ENGINE RETARDER BUZZER PRESSURE L144EF WHT/L_GRN WIRE0533 A TO ENGINE
WARN LP & WARN LAMP WARN LAMP ENGINE WARN LP & WARN LP SWITCH N/C HARNESS
BUZZER DIP SW WARN BUZZER DIP SW (SHOWN W/ B
LAMP FAN ON)
B CONTINUED ON
USAGE NOTE:
SHT 3, ZONE J15
USE ON BI, BII, BIII CABS FOR CAT C10/C12 OR
P18WL L_GRN WIRE0534 C15/C16 ELECTRONIC ENGINES W/ ADEM III CONTROLLE

J99 5 10 6 4 3 2 7 8 11 12 1 9 J41 2 6 4 3 1 5 8 7
COOLING
24 25 CAB S7 MODULE
ROOF J78 HARN P21 31
CAB J76
ROOF HARNESS OPEN CIRCUIT =
B B D

L95ER BLK/LTGRN WIRE0055

FAN ON P144EF WHT/LTGRN WIRE0541 CONNECT FOR

L158WL BRN/ORN WIRE0046

L159WL BRN/WHT WIRE0048

L58LO GRN/BRN WIRE0039

HARNESS
L144EF WHT/L_GRN WIRE0585

E95ER BLK/LT_GRN WIRE0111 A CUMMINS ISX

L56LC LTGRN/BLU WIRE0042

A A C144EF WHT/LTGRN WIRE0535 F & SIGNATURE

L58HW GRN/BRN WIRE0396

UNITARY SWITCH E98ER LT_GRN/BLK WIRE0099 B ENGINES ONLY

(A/C HIGH PRESS P39 H
SWITCH N/C) TO P53
G ENGINE
S8 HARNESS J52
E
E97ER LT_BLU/GRN WIRE0100 A CONNECT FOR
OPEN CIRCUIT = B B C102FC L_GRN/WHT WIRE0539 C CUMMINS ISM
C B
A/C COMPRESSOR OFF E96ER LT_GRN/YEL WIRE0098 ENGINES ONLY
A A C102FCA L_GRN/WHT WIRE0537 A
CONTINUED ON P54
J75 B SHT 3, ZONE I15
BINARY
SWITCH

H
TO 28
L95ER BLK/LTGRN WIRE0055 G E96ER LT_GRN/YEL WIRE0097
INSTRUMENT
LOW A E208LC GRY WIRE0549
PANEL HARNESS
COOLANT
SENSOR B E205LC BLU/BLK WIRE0550

L58HW GRN/BRN WIRE0396 B CONTINUED ON J92

SHT 4, ZONE K16 29
L56LC LTGRN/BLU WIRE0042 A COOLING J53 S9
H MODULE
P70 OPTIONAL HARN C
2-WIRE F E96ER LT_GRN/YEL WIRE0079 B
14 A
LOW COOLANT 38
SENSOR E E98ER LT_GRN/BLK WIRE0080 29 D
22 E
TO D E95ER BLK/LT_GRN WIRE0096 F
INSTRUMENT 26
PANEL HARNESS C
L95ER BLK/LTGRN WIRE0085 ENGINE
27 RETARDER
B P18WL L_GRN WIRE0084 SELECTOR
SWITCH
J98 12 M A E98ER LT_GRN/BLK WIRE0101

P18WL L_GRN WIRE0109

A CONTINUED ON J74

E97ER LT_BLU/GRN WIRE0081

SHT 4, ZONE J3 19 SWITCH
B HARNESS
TO
C INSTRUMENT
PANEL HARNESS
H

E 29
J50 S10
F
CONTINUED ON
L58LO GRN/BRN WIRE0039 G SHT 4, ZONE I16 B A

D K
E F 29
J54 S11

E69CM GRY WIRE0105

ENGINE C
RETARDER E69CM GRY WIRE0087 B
ON-OFF A
SWITCH D
CONTINUED ON E
J47 L F
SHT 4, ZONE F16
29
L144EF WHT/L_GRN WIRE0585 CRUISE
TO (ABS) J51 S12 CONTROL
P69 J94 SET/RES
INSTRUMENT
PANEL HARNESS 31 30 SWITCH
L159WL BRN/WHT WIRE0048 A E69CM GRY WIRE0076 B A

L158WL BRN/ORN WIRE0046 B P52

E F
C CONTINUED ON
L SHT 4, ZONE E16
CRUISE
CONTROL
ON-OFF
SWITCH
J93
I.D. 26 CRUISE
B L13LI GRY WIRE0095 LAMP SWITCHE
CONTINUED ON REMOTE
A J77 MOUNTED
SHT 4, ZONE B3 E69CM GRY WIRE0074
TO
P INSTRUMENT F E139CT ORN/BRN WIRE0094 E69CM GRY WIRE0075 B
F PANEL HARNESS 32
THROTTLE D E140CT ORN/RED WIRE0088 E140CT ORN/RED WIRE0088 A
A PEDAL EXT 33
HARNESS E E141CT ORN/GRN WIRE0091 E141CT ORN/GRN WIRE0091 C
TO B J63
INSTRUMENT N C E31CT YEL/PUR WIRE0086 D
E31CT YEL/PUR WIRE0086
PANEL HARNESS D A A CONTINUED ON
E129CT BRN/GRN WIRE0117 THROTTLE POSITION
SHT 4, ZONE H3 P51 P55
SENSOR (MOUNTED
C E128CT BRN/RED WIRE0115 B B ON THROTTLE SWITCH
17
PEDAL ASSEMBLY) HARNESS
E E127CT BRN/GRY WIRE0113 C C (PWM SIGNAL)
P59 P66
30
CAT Engine Diagram P94-1298 C 06

DETAIL "A" DETAIL "B"

J1939 DATA LINK WIRING (CAB SIDE) J1939 DATA LINK WIRING (ENGINE SIDE)
USAGE NOTE:
CONTINUED ON USE ON BI, BII, BIII CABS FOR CAT C10/C12 OR
SHT 4, ZONE J12 TERMINATING C15/C16 ELECTRONIC ENGINES W/ ADEM III CONTROLLER
J1939 T-CONNECTOR
RESISTOR
J 28
J44
A2 A1 A
120 OHM
TO J1939 DATA
LINK BREAKOUT IN B2 B1 B
THE INSTR PNL HARN
C2 C1 C

C3 B3 A3 J45 CONTINUED ON TO ENGINE

SHT 3, ZONE E2 HARNESS REMOVE TERMINATING
S RESISTOR FROM ENGINE
C B A HARNESS AND CONNECT
C B A
J40 BACKBONE HARNESS
J11 TO ENGINE HARNESS

CAN_SHLDBARE WIRE0426

CAN_H YEL WIRE0428

CAN_L GRN WIRE0427
J1939 J1939

CAN_SHLDBARE WIRE0454
BACKBONE BACKBONE
HARNESS HARNESS

CAN_L GRN WIRE0455

CAN_H YEL WIRE0456

J1939 T-CONNECTOR
TERMINATING
J42 28 RESISTOR
J43
J39 A A2 A1 A 120
C B A OHM
J1939 B B2 B1 B
PASS-THRU
HARNESS C2 B2 A2 C C2 C1 C
J38 J37
C3 B3 A3 J10 TERMINATING RESISTOR
28
CAN_SHLDBARE WIRE0424 1 C C3 REMOVED FROM ENGINE
HARNESS AND CONNECTED
B B3 J1939 T-CONNECTOR TO T-CONNECTOR
CAN_L GRN WIRE0425 TO SAE COMPATIBLE
A A3 DEVICE/COMPONENT
CAN_H YEL WIRE0598
STUB CONNECTION
G P36 SUCH AS A ELECTRONIC
C B A C1 B1 A1 CONTROLLED TRANS
CONTINUED ON
SHT 3, ZONE J2 TO ENGINE
HARNESS OPTIONAL J1939

(OPTIONAL TRANSMISSION
OR OPTIONAL ABS W/ ATC)

TO ENGINE
HARNESS BATTERY BOX

G
8 4 6 5 7 2 1 3
CONTINUED ON
11 P75
E150SP BLU/RED WIRE0551
E150SU BLU/RED WIRE0552

SHT 3, ZONE G3
C19SR_2 TAN WIRE0561

G026SU VIO WIRE0556

AMP
C19SR TAN WIRE0559

135
GND_HWHT WIRE0555

SEE CHARGE
AND START PWR1 RED WIRE0366
CAT CHASSIS
DIAGRAM
HARNESS
F2
POS

PWR1 RED WIRE0373 G1

BATTERY BOX GND1 WHITE WIRE0368 NEG

P76 11 EXT HARNESS
8 4 6 5 7 2 1 3 J97
C B A
8 4 6 5 7 2 1 3
10 J60 20 30 C B A P68
C19SR_2 TAN WIRE0562

E150SP BLU/RED WIRE0554

E150SU BLU/RED WIRE0553

AMP AMP
GND_HWHT WIRE0599

G26SU VIO WIRE0600

A 32 F04
C19SR TAN WIRE0560

TRANSMISION A B C D E F
HARNESS
E181CP4 RED WIRE0422
E181CP3 RED WIRE0423

J100

POWER FUSE
A B HARNESS

NEUTRAL P77 CONTINUED ON G

SHT 3, ZONE D3 71
START SEE OPTIONAL E181CP RED WIRE0419
CHARGE TRANS 2 E181CP1 RED WIRE0417
AND START TEMP TO ENGINE
DIAGRAM J61 SENSOR HARNESS 1 E181CP2 RED WIRE0418
SPEED_SENSOR TSENDER1 J96