HAM M OND

SERVICE MANUAL
CAUTION !
XK-1 See safety notice inside

JUL.2006

SUZUKI MUSICAL INST.MFG.CO.,LTD.

25-12,RYOKE 2-CHOME,HAMAMATSU, JAPAN
 SAFETY NOTICE
Great care has been taken in the design and manufacture of this product to assure that no shock hazard exists on any exposed
metal parts. Internal service operations can expose the technician to hazardous line voltages and accidentally cause these
voltages to appear on exposed metal parts during repair or reassembly of product components. To prevent this, work on these
products should only be performed by those who are thoroughly familiar with the precautions necessary when working on this
type of equipment.

To protect the user, it is required that all enclosure parts and safety interlocks be restored to their original condition and the
following tests be performed before returning the product to the owner after any service operation.

Plug the AC line cord directly into a line voltage AC receptacle (do not use an isolation transformer for this test) and turn the
product on. Connect the network (as shown below) in series with all exposed metal parts and a known earth ground such as a
water pipe or conduit. Use an AC Voltmeter of 5,000 ohms per volt or higher sensitivity to measure the voltage drop across the
network. Move the network connection to each exposed metal part (metal chassis, screw heads, knobs and control shafts,
escutcheon, etc.) and measure the voltage drop across the network. Reverse the line plug and repeat the measurements. Any
reading of 4 volts RMS or more is excessive and indicates a potential shock hazard which must be corrected before returning
the product to the user.

VOM
AC SCALE
10K
2W

0.01MF
CERAMIC RF
BYPASS CAP

TEST TEST CLIPS

PROBE
CONNECTED TO KNOWN
EARTH GROUND
TO EXPOSED METAL PARTS

CAUTION
Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type recommended by the
equipment manufacturer. Discard used batteries according to manufacturer's instructions.
Advarsell
Lithiumbatteri. Eksplosionsfare ved fejlagtig håndering.
Udskiftning må kun ske med batteri as samme fabriket og type.
Lebér det brugte batteri tilbage til leverandoren.

Norge: ADVARSEL
Lithiumbatteri - Eksplosjonsfare.
Ved utskiftning benyttes kun batteri som anbefalt av apparatfabrikanten.
Brukt batteri returneres apparatleverandoren.

Sverige: VARNING
Explosionsfara vid felaktigt batteribyte.
Använd samma batterityp eller et ekvivalent typ som
rekommenderes av apparattillverkaren,
Kassera använt batteri enlig fabrikantens instruktion.

Finland: VAROITUS
Paristo voi räjähtää, jos se on virheeliseeti ansennettu
Vaihda paristo ainoastaan laitevalmistajan suosittelemaan
tyyppoonn, Hävitä käytetty paristo valmistajan ohjeiden mukaisesti.
 XK-1

-Table of Contents-

1.SPECIFICATIONS 1
2.BLOCK DIAGRAM 2
3.TEST AND ADJUSTMENT 3
4.WIRING CONNECTION 4
5.WIRING CHART 5-1,5-2
6.PRINTED WIRING BOARD ASS'Y LIST 6
7.SCHEMATICS
MGH-94A 1/9~9/9 7-1 ~ 7-9
SWH-510A 7-10
SWH-511A 7-11
SWH-512A 7-12
8.PARTS LIST 8-1~8-6
9.DISASSEMBLING PROCEDURE 9
10.WARNING 10
11.TECHNICAL DESCRIPTION 11-1,11-2
12.RESET AND SOFTWARE VERSIONS 12
 XK-1
1.Specifications
Sound Generator 2 x VASE3 as
Digital Tone-wheels
Keyboard 61 notes
Water Fall type with Velocity
Harmonic Drawbars
Knobs 9 Pitches
Drawbar Select Tabs Upper, Pedal, Lower
Waveform B-type/ Mellow/ Brite (Upper and Lower)
Muted/ Normal / Synth 1/ Synth 2 (Pedal)
Percussi on
Tabs Second On, Third On, Fast Decay, Soft
Adjustable Touch, Velocity, Decay (Fast, Slow), Level (Soft, Normal)
Extra Voi ce 8 Instruments
Tuni ng
Master 430 - 450 1Hz Steps
Transpose -6 - 0 - +6 semitones
Effects
Internal Leslie On, Fast, Brake
Digital, 2 Rotors
Vibrato and Chorus V1, V2, V3, C1, C2, C3
Upper & Lower On / Off
Speed : 5 (6.10 - 7.25 Hz)
Overdrive Digital Overdrive
Equalizer 3 Bands
Reverb 10 Programs
Sustain 5 Lengths (Pedal)
Internal Zone
Tabs Split, Manual Bass
Adjustable Map Low, High
Split Point, Lower Octave, Pedal Top Key

Combi nati on Presets 12 banks x 11 Numbers

+ Adjust
Switchable : Link / Independent
Control l ers
Switches Power On / Off
Rotary Controllers Master Volume, Overdrive, Tone
Wheels Pitch Bend, Modulation
Di spl ay 20-characters, 2 lines with 9 control switches and Rotary encoder
Storage None
M IDI Templates : 3 modes
Zoned 3 parts and keyboard Ch.
Connecti ons AC Inlet
MIDI In 1, In 2, Out
Exp.Pedal (Phone Jack), Foot Switch,
Line Out L / Mono, R,
Headphones, 8-pin Leslie
Di mensi on 116 (W) x 33.4 (D) x 11(H) cm
Wei ght 13.5 kg

1
 XK-1

PITCH MODULA
SWH-512A SWH-510A SWH-511A BENDER TION
ENDBLOCK PANEL L PANEL R
(VIBRATO, LESLIE) (MASTER VOLUME, (PRESET, MENU, PLAY etc)
CONTROL, TONE, REVERB etc)

J115

J106 J104 J105 J111

+3.3V BT1
12.5MHz
CR2032
(3V)
DRAWBARS

J110
+5V +1.26V U11
25MHz RESET
RESET IC
U27 U19
DC-DC U2 DSP 128Kx16bit
R1224N SRAM U1
(+1.26V) VIBRATO OVER MAIN CPU U15,U44
CHORUS DRIVE HD6417144 512k*8
+3.3V (SH-2) SRAM
+5V 50MHz
20LINE * 2

J103
U26
DC-DC TONE/ LESLIE REVERB
EXP EFFECT EFFECT
U29
VASE3
LCD UNIT
R1224N MASTER U14
(+3.3V) 64POLY TONE 16M FLASH
GENERATOR

+5V +5VAN +8V

U43
U30
VASE3
MGH-94A
SWITCHED U28 SLAVE MAIN CPU & GENERATOR
SWITCHING POWER SUPPLY CAPACITOR DAC 64POLY TONE
-8V PCM1791ADB GENERATOR
J107

JRC AES10-5 VOLTAGE

P51
P1

+5V CONVERTER 25MHz

LT1054CDW
(+8V,-8V) U32
WAVE ROM

J114
U41
+5VAN +8V +5VAN +5VAN
KEYSCAN
CPU
U10 U9 U8 HD64F3024F
J115

U7 DETECT, FAST, SLOW

4556M 4580M 4580M 4580M (H8)

J113
OPAMP OPAMP OPAMP OPAMP
H.P. AM LINE AMP LPF UNBAL
MASTER
-8V VOLUME -8V -8V

POWER SWITCH

JACK2
JACK4

JACK6

JACK5

JACK3
JACK7 JACK1

MIDI OUT

MIDI IN1

MIDI IN2
LINE OUT L/MONO

LESLIE 8-PIN
HEADPHONES

LINE OUT R

61KEYS KEYBOARD

AC IN 100 - 240V
50/60 Hz

EXP. PEDAL FOOT SWITCH

V-20R FS-9H
XK-1

2.BLOCK DIAGRAM
 XK-1

XK-1

3.TEST AND ADJUSTMENT

 XK-1

J114
J113
MGH-94A SWITCHING POWER AC
WR-HZ133-A
POWER SUPPLY SWITCH INLET
J115 P51 AES10-5 P1

J103

J110 J107
WR-HZ133-H WR-HZ133-G
J111 J105 J104 J106

Ferrite core

WR-HZ133-J
WR-HZ133-J
TFT-152613N
with TFB-2024RS
WR-HZ133-B
DRAWBAR
ASSY

02,0181-A26613330 02,0182-A26613340

WR-HZ133-C WHEEL
FATAR KEYBOARD ASSY
TP/8O J401
SWH-512A

WR-HZ133-D
WR-HZ133-E

J301 J201 J202

LCD UNIT
SWH-511A SC2002AUOT-SOGB-XXX SWH-510A

WR-HZ133-F

XK-1

4.WIRING CONNECTION
5.WIRING CHART XK-1

MAIN PLUG FROM TO PLUG WIRE TO PWB FUNCTION

MGH-94A No. PIN No. & PIN NO. COLOR NAME
PLUG FROM TO PLUG WIRE TO PWB FUNCTION J110 1 DB-1 WHT DB-209 GND
No. PIN No. & PIN NO. COLOR NAME 2 2 BLK 4'
J103 1 1 RED LCD UNIT VSS 3 3 BLK 2'
2 2 VDD 4 4 BLK 1'
3 3 VO 5 5 BLK 1 3/5'
4 4 RS 6 6 BLK 8'
5 5 R/W 7 7 BLK 16'
6 6 E 8 8 BLK 1 1/3'
7 7 DB0 9 9 BLK 2 2/3'
8 8 DB1 10 10 BLK 5 1/3'
9 9 DB2 11 11 BLK +3.3V
10 10 DB3 12 12 BLK NC
11 11 DB4 J111 1 M-3, P-1 YEL WHEEL +3.3V
12 12 DB5 2 P-2 RED ASS'Y PITCH
13 13 DB6 3 M-2 WHT MOD
14 14 DB7 4 M-1, P-3 BLK GND
15 15 A J113 1 L-1 RED KEYBOARD KCOM0
16 16 K 2 2 DK0
J104 1 J201-1 BRN SWH-510A COM0 3 3 KCOM1
2 2 RED COM1 4 4 DK1
3 3 ORG COM2 5 5 KCOM2
4 4 PNK COM3 6 6 DK2
5 5 GRN COM4 7 7 KCOM3
6 6 BLU GSW0 8 8 DK3
7 7 VIO GSW1 9 9 KCOM4
8 8 GRY GLED0 10 10 DK4
9 9 WHT GLED1 11 11 KCOM5
10 10 YEL +3.3V 12 12 DK5
11 11 BRN O.D. 13 13 KCOM6
12 12 RED TONE 14 14 DK6
13 13 BLK GND 15 15 KCOM7
J105 1 J301-1 ORG SWH-511A GLED4 16 16 DK7
2 2 PNK GLED3 J114 1 H-1 RED KEYBOARD KCOM0
3 3 GRN GLED2 2 2 DK8
4 4 BLU GSW5 3 3 KCOM1
5 5 VIO GSW4 4 4 DK9
6 6 GRY GSW3 5 5 KCOM2
7 7 WHT GSW2 6 6 DK10
8 8 BRN COM0 7 7 KCOM3
9 9 RED COM1 8 8 DK11
10 10 ORG COM2 9 9 KCOM4
11 11 PNK COM3 10 10 DK12
12 12 GRN COM4 11 11 KCOM5
14 13 BLU ROT A 12 12 DK13
13 14 VIO ROT B 13 13 KCOM6
15 15 BLK GND 14 14 DK14
J106 1 J401-1 BRN SWH-512A GSW5 15 15 KCOM7
2 2 RED GLED1 16 16 DK15
3 3 ORG COM0 J115 1 J202-1 BLK SWH-510A AGND
4 4 YEL COM1 2 2 WHT OUT L
5 5 GRN COM2 3 3 RED OUT R
6 6 BLU COM3 4 4 WHT IN L
5 5 RED IN R
7 7 VIO COM4 6 6 BLK AGND
8 8 GRY GSW6
9 9 WHT GLED5
J107 1 P51-1 BLK POWER DG
2 2 BLK SUPPLY DG
3 3 YEL +5V
4 4 YEL +5V

5-1
XK-1

PANEL SW L PLUG FROM TO PLUG WIRE TO PWB FUNCTION

SWH-510A No. PIN No. & PIN NO. COLOR NAME
PLUG FROM TO PLUG WIRE TO PWB FUNCTION
No. PIN No. & PIN NO. COLOR NAME
J201 1 J104-1 BRN MGH-94A COM0
2 2 RED COM1
3 3 ORG COM2
4 4 PNK COM3
5 5 GRN COM4
6 6 BLU GSW0
7 7 VIO GSW1
8 8 GRY GLED0
9 9 WHT GLED1
10 10 YEL +3.3V
11 11 BRN O.D.
12 12 RED TONE
13 13 BLK GND
J202 1 J115-1 BLK MGH-94A AGND
2 2 WHT IN L
3 3 RED IN R
4 4 WHT OUT L
5 5 RED OUT R
6 6 BLK AGND
PANEL SW R
SWH-511A
J301 1 J105-1 ORG MGH-94A GLED4
2 2 PNK GLED3
3 3 GRN GLED2
4 4 BLU GSW5
5 5 VIO GSW4
6 6 GRY GSW3
7 7 WHT GSW2
8 8 BRN COM0
9 9 RED COM1
10 10 ORG COM2
11 11 PNK COM3
12 12 GRN COM4
13 13 BLU ROT A
14 14 VIO ROT B
15 15 BLK GND
END BLOCK SW
SWH-512A
J401 1 J106-1 BRN MGH-94A GSW5
2 2 RED GLED1
3 3 ORG COM0
4 4 YEL COM1
5 5 GRN COM2
6 6 BLU COM3

7 7 VIO COM4
8 8 GRY GSW6
9 9 WHT GLED5

5-2
6.PRINTED WIRING BOARD ASS'Y LIST XK-1

FUNCTION PWB.NAME PART No.

MAIN MGH-94A 00228-25216

PANEL L SWH-510A 00225-42236

PANEL R SWH-511A 00225-42241

ENDBLOCK SWH-512A 00225-42246

-6-
 A[0..17]
XK-1
A[0..17]
D[0..15]
D[0..15]

+3.3V U12
A19 1 15 S RAM CE
A Y0 S RAM CE
A20 2 14 PIN_CE
B Y1 PIN_CE
+3.3V R21 A21 3 13 DSP_CE U15
C Y2 DSP_CE
10k 12 KEYSCAN_CE A1 20 21 D0
M CSB Y3 KEYSCAN_CE A0 D0
11 POUT_CE A2 19 22 D1
Y4 POUT_CE A1 D1
R20 MIDI OUT M CSB 4 10 A3 18 23 D2
MIDI OUT E1 Y5 A2 D2
10k CS3 5 9 A4 17 25 D3
LM MIDI IN U1 E2 Y6 A3 D3
LM MIDI IN 6 7 A5 16 26 D4
50 4 A0 E3 Y7 A4 D4
KEY RXD1 R115 100 PA1/TXD0 PC0/A0 +3.3V A6 15 27 D5
KEY TXD1 47 5 A1 A5 D5
KEY TXD1 PA4/TXD1 PC1/A1 +3.3V 16 A7 14 28 D6
51 6 A2 Vcc C98 A6 D6
R116 100 PA0/RXD0 PC2/A2 A8 13 29 D7
KEY RXD1 48 7 A3 A7 D7
PA3/RXD1 PC3/A3 8 A9 3
KEY IREQ 8 A4 GND 0.1u A8
KEY IREQ PC4/A4 A10 2
LCD RS 49 9 A5 A9
LCD RS PA2/SCK0/DREQ0/IRQ0 PC5/A5 74LV138APW A11 31
RA1 4-100 46 10 A6 A10
PE0 PA5/SCK1/DREQ1/IRQ1 PC6/A6 A12 1
11 A7 A11
FOOTSW_T PC7/A7 A13 12
85 +3.3V A12
MC PE0/TIOC0A/DREQ0 R27 A14 4
86 12 A8 A13
KEYSCAN RESET PE1/TIOC0B/DRAK0 PC8/A8 A15 11
R120 100 87 13 A9 10k A14
VASE_RESET PE2/TIOC0C/DREQ1 PC9/A9 A16 7
R241 88 14 A10 A15
A17
+3.3V MUTE
10K AMUTE
89
102
PE3/TIOC0D/DRAK1
PE4/TIOC1A/RXD3
PC10/A10
PC11/A11
15
16
A11
A12
NOT USED A18
10
6
A16
A17
CE
WE
30
5
R22 AMUTE PE5/TIOC1B/TXD3 PC12/A12 A19 9 32
MUTE 104 17 A13 A18 OE

J101
R28
10k
R97
10k
10K PED MIDI IN
PED MIDI IN
S_VASE_BUSY
105
106
PE6/TIOC2A/SCK3
PE7/TIOC2B/RXD2
PC13A13
PC14/A14
18
19
A14
A15
NOT USED RAM Vcc

S_VASE_BUSY PE8/TIOC3A/SCK2 PC15/A15 R114 8

1 M_VASE_BUSY 107 U16 VCC
+3.3V FOOTSW_R M_VASE_BUSY PE9/TIOC3B/SCK3 C11
2 108 20 A16 10k A0 12 13 D0
PE10 PE10/TIOC3C/TXD2 PB0/A16 A0 D0 0.1u 24
3 110 22 A17 R117 A1 11 14 D1 GND
RXD3 PE11/TIOC3D/RXD3 PB1/A17 A1 D1
4 111 29 A18 A2 10 15 D2
TXD3 PE12/TIOC4A/TXD3 PB6/IRQ4/A18/BACK 10k A2 D2 IC62LV5128LL-55H
5 BAT DETCT 112 30 A19 A3 9 17 D3
PE0 PE0 BAT DETCT PE13/TIOC4B/MRES PB7/IRQ5/A19/BREQ R123 A3 D3
6 ANSEL0 1 31 A20 A20 A4 8 18 D4
NC ANSEL0 PE14/TIOC4C/DACK0 PB8/IRQ6/A20/WAIT A4 D4 WRL
7 ANSEL1 2 32 A21 A21 10k A5 7 19 D5
GND ANSEL1 PE15/TIOC4D/DACK1/IRQOUT
PB9/IRQ7/A21/ADTRG A5 D5
+3.3V EXPIN R124 A6 6 20 D6
JP1 EXPIN A6 D6 U44
B7B-PH-K-S DRB0 91 A7 5 21 D7
DRB0 PF0/AN0 10k A7 D7 A1 20 21 D8
DRB1 92 70 D0 A8 27 A0 D0
JP2 DRB1 PF1/AN1 PD0/D0 A8 A2 19 22 D9
DRB2 93 69 D1 U4A A9 26 22 CS0 A1 D1
A3 D10
NOT USED DRB2
PITCH
PITCH 94
95
PF2/AN2
PF3/AN3
PD1/D1
PD2/D2
68
67
D2
D3
1
2
3
S_VASE_CE
A10
A11
23
25
A9
A10
CE
OE
24 RD
A4
18
17
A2
A3
D2
D3
23
25 D11
MOD PF4/AN4 PD3/D3 A11 A5 16 26 D12
MOD 96 66 D4 74LV32APW A12 4 A4 D4
OD PF5/AN5 PD4/D4 A12 A6 15 27 D13
OD 98 64 D5 A13 28 1 A5 D5
TONE PF6/AN6 PD5/D5 U4C A13 Vpp A7 14 28 D14
TONE 99 63 D6 9 A14 29 A6 D6
PF7/AN7 PD6/D6 8 A14 A8 13 29 D15
62 D7 10 M_VASE_CE A15 3 +3.3V A7 D7
PD7/D7 A15 A9 3
R24 79 A16 2 32 A8
Normal MD0 74LV32APW A16 Vcc A10 2
78 60 D8 A17 30 A9
10k MD1 PD8/D8 LCD_CE A17 C100 A11 31
75 59 D9 LCD_CE A18 31 16 A10
C99 +3.3V MD2 PD9/D9 A18/PRG GND 0.1u A12 1 RAM Vcc
73 58 D10 A11
0.01u MD3 PD10/D10 WRH A13 12
TEST1 57 D11 REA-32DP-32SP A12
PD11/D11 A14 4
NOT USED 84 56 D12 A13
RES PD12/D12 U3A A15 11 R94
RESET TEST2 54 D13 1 A14
JP3 PD13/D13 3 RD A16 7 10K
76 53 D14 2 A15
NMI PD14/D14 A17 10 30
for Debugger 52 D15 A16 CE
R79 0 PD15/D15 74LV08APW A18 6 5
72 A17 WE
XTAL A19 9 32
+3.3V 74 34 A18 OE
C6 EXTAL PA14/RD
36 WRH +3.3V
RAM Vcc
15p PA13/WRH A19
83 38
X1 PA15/CK PA12/WRL WRL 8
R23 C1 35 VCC
R1 10u/50V 100 WDTOVF C14
10K
C7 12.5MHz 97
AVcc R18 R17 R16 R25 U14 16M FLASH
0.1u 24
GND
10 AVss 10k 10k 10k 10k
15p 44 CS3 A1 25 29 D0
PA7/TCLKB/CS3 A0 DQ0 IC62LV5128LL-55H
21 45 CS2 A2 24 31 D1
+3.3V Vcc PA6/TCLKA/CS2 A1 DQ1
+3.3V 37 40 CS1 A3 23 33 D2
Vcc PA11/CS1 A2 DQ2
65 41 CS0 A4 22 35 D3
Vcc PA10/CS0 A3 DQ3
FWP 77 +3.3V A5 21 38 D4
Vcc(FWP) R92 10k JP5 A4 DQ4 WRH
103 43 A6 20 40 D5
Vcc PA8/TCLKC/IRQ2 ROT A A5 DQ5
C3 C13 42 A7 19 42 D6 S RAM CE
C4 PA9/TCLKD/IRQ3 ROT B A6 DQ6 S RAM CE
0.1u +3.3V A8 18 44 D7
0.1u 0.1u 3 24 R93 10k A9 8
A7 DQ7
30 D8 TEST3 RD
Vss PB2/IRQ0/POE0/SCL0 DSP RESET A8 DQ8
23 25 A10 7 32 D9 TEST4
Vss PB3/IRQ1/POE1/SDA0 LCD R/W U3C A9 DQ9
33 26 9 A11 6 34 D10 TEST5
Vss PB4/IRQ2/POE2/CS6 8 A10 DQ10
39 28 CS7 10 A12 5 36 D11 TEST6
Vss PB5/IRQ3/POE3/CS7 A11 DQ11
55 R83 C95 A13 4 39 D12 TEST7
Vss 74LV08APW A12 DQ12
61 81 A14 3 41 D13 TEST8
Vss PLLCAP 3300 R100 470p A13 DQ13
71 80 +3.3V A15 2 43 D14 TEST9
90
Vss PLLVcc
82
+3.3V R26 A16 1
A14 DQ14
45 D15 TEST10
Vss PLLVss C8 220 A15 DQ15A-1
101 0.1u 10k A17 48
Vss A16 NOT USED U3E
109 27 A18 17 +3.3V
Vss ASEBRKAK A17
A19 16 10 U3B 14
A18 NC 4 VCC
HD6417144(ROMLESS) A20 9 13 6 C101
A19 NC 5
14 0.1u 7
NC GND
WRH 11 74LV08APW
W
26 +3.3V
E C9 74LV08APW
RD 28 37
G Vcc
RESET 12 C2
RP 0.1u
47 27
+3.3V BYTE Vss 10u/50V
15 46
RAM Vcc +5V RB Vss
M CSB R96

R125
47k
MX29LV160BBTC-70G
CPU SYSTEM
47k
C97 R95 Q11
M CSB 2SC4116GR
R111 4700
4.7uF/50V LLA Q1
BAT DETCT 2SC4116GR
4700
R126
3

JP1 JP2 JP5 3300

Debug X O X 1 8 XK-1
COM

Vout CS OUT
V BATT
On Flash O X O R110 D1 V BATT
2 7
1SS181
560
3
Vbat RESE OUT
6 BT1
R112
22K
MGH-94A(1/9)
2

+3.3V Vin GND

4 5

C96
Ct RESE OUT
( CR2032 3V ) 00228-25216
4.7uF/50V LLA HL32-A2
U11 M62023FP 7-1
 D[0..15]
D[0..15] XK-1

U6A
R146 KD[0.. 7]
1 16 KD[0.. 7]
GLED0
22
U6B
+3.3V
2 15 R144
GLED1
U18
22
R29 U24 U6C D0 2 18 KD0
A0 B0
POUT_CE U4B 10K 1 19 D1 3 17 KD1
4
6 11
OE Q0
18 3 14 R147 D2 4
A1 B1
16 KD2
5 CK Q1 GLED2 A2 B2
WRH 17 D3 5 15 KD3
Q2 22 A3 B3
74LV32APW 16 U6D D4 6 14 KD4
Q3 A4 B4
D0 2 15 D5 7 13 KD5
D0 Q4 R145 A5 B5
D1 3 14 4 13 D6 8 12 KD6
D1 Q5 GLED3 A6 B6
D2 4 13 D7 9 11 KD7
D2 Q6 MD 22 A7 B7
D3 5 12 U6E +3.3V
D3 Q7 MS
D4 6 +3.3V KEYSCAN_CE 19 20
D4 R148 KEYSCAN_CE E Vcc
D5 7 20 5 12 1 C103
D5 Vcc GLED4 RD DIR
D6 8 10 0.1u
D6 C102 22 GND
D7 9 10 U6F
D7 GND 0.1u
R149 74LV245APW
74LV574APW 6 11
GLED5
22
U6G
7 10 U6 TD62003F :TOSHIBA
ULN2003L :SPRAGUE(ALLEGRO)
ULN2003D :SGS/THOMSON 100pF x 19

ULN2003ANS :T.I. J104

MC1413D :MOTOROLA FB6 1
COM0 COM0
+3.3V FB7 2
COM1 COM1
U25 Q2 FB8 3
R2 COM2 COM2
1 19 FB9 4
OE Q0 COM3 COM3
11 18 1000 FB10 5
CK Q1 COM0 COM4 COM4
17 Q3 R139 1200 C248 6
Q2 R3 COM1 GSW0 GSW0
16 R140 1200 C249 7
Q3 COM2 GSW1 GSW1 TO SWH-510A
D8 2 15 1000 R141 1200 C250 8
D0 Q4 COM3 GLED0 GLED0
D9 3 14 Q4 R142 1200 +3.3V C252 9
D1 Q5 LES SLOW R4 COM4 GLED1 GLED1
D10 4 13 R143 1200 FB44 10
D2 Q6 LES FAST +3.3V
D11 5 12 1000 R129 100 C251 11
D3 Q7 V PED SEL OD O.D.
D12 6 +3.3V Q5 R130 100 C253 12
D4 R5 TONE TONE
D13 7 20 13
D5 Vcc GND
D14 8 C105 1000
D6
D15 9 10 0.1u Q6 B13B-PH-K-S
D7 GND R6
74LV574APW 1000
J105
Q2-Q6:2SB852K
C125 1
GLED4 GLED4
C126 2
GLED3 GLED3
C127 3
GLED2 GLED2
C128 4
GSW5 GSW5
U19 C129 5
GSW4 GSW4
C130 6
D0 2 18 B0 GSW3 GSW3
D1
A0 B0
17 B1 C131 7
3 GSW2 GSW2
A1 B1 FB34 8 TO SWH-511A
D2 4 16 B2 COM0 COM0
A2 B2 FB35 9
D3 5 15 B3 COM1 COM1
A3 B3 FB36 10
D4 6 14 B4 COM2 COM2
A4 B4 FB37 11
D5 7 13 B5 COM3 COM3
A5 B5 FB38 12
D6 8 12 B6 COM4 COM4
A6 B6 R14 100 C254 13
D7 9 11 B7 RA2 ROT A ROT A
A7 B7 R15 100 C255 14
+3.3V 8-100 ROT B ROT B
B6 15
19 20 GND
E Vcc B4 R138 +5V
RD 1 C104 2.2 1/2W
RD DIR B2 J103 B15B-PH-K-S
10 0.1u
GND B0 16 15
B7 C114 14 13 C124 +5V
74LV245APW C115
B5 12 11 C112 J106
B3 C119 10 9 C120 C256 1
GSW5 GSW5
U5A B1 C118 8 7 C121 R30 C257 2
GLED1 GLED1
LCD_CE 1 2 R121 100 C117 6 5 C122 FB4 10K FB39 3
LCD_CE COM0 COM0
R122 100 C116 4 3 C123 FB5 FB40 4
COM1 COM1
74LV04APW C113 2 1 FB41 5
COM2 COM2 TO SWH-512A
LCD RS FB3 100pF x 13 R80 FB42 6
LCD RS COM3 COM3
+5V XG4C-1631 330 FB43 7
COM4 COM4
C258 8
GSW6 GSW6
C259 9
GLED5 GLED5
LCD R/W
LCD R/W
B9B-PH-K-S
LCD I/F
NO. SYMBOL NO. SYMBOL
16 K 15 A
14 DB7 13 DB6
12 DB5 11 DB4
10 DB3 9 DB2
8
6
DB1
E
7
5
DB0
R/W KeyScan & I/O SIO
4 RS 3 VO
U5D 2 VDD 1 VSS
9 8
+3.3V U5G U6H
14
74LV04APW C15 VCC +3.3V
0.1u 9
U5E 7 VCC
GND
11 10
74LV04APW
C16 XK-1
8 0.1u
74LV04APW GND

13
U5F
12 TD62003F
MGH-94A(2/9)
74LV04APW
00228-25216
7-2
 XK-1

C245
0.1u

J107 R173 +5VAN

4 2.2 1/2W
+5V
3
+5V C159
2
GND 2200u/6.3V
1
GND C147 +3.3V +1.26V C148
10uF/20V OS
B4B-XH-A (LF)(SN) JP10 JP11 JP12
10uF/20V OS
U2B
B19 C17 0.1u
CVDD
B13 B2
C34 DVDD CVDD C18
0.1u B8 A12 0.1u
DVDD CVDD
10uF/20V OS B3 A10
+5V C35 DVDD CVDD C19
C141 0.1u A17 A9 0.1u C144
Q7 DVDD CVDD 10uF/20V OS
F3 D6
FB1 HAT1044MWS-E DVDD CVDD
D6 0.1u C36 D19 D5 C20 0.1u
NFM21PC104R1ED3 +5V +3.3V DVDD CVDD
1 2 4 1,2,5,6 L1 RD2.0PB1 1W D16
DVDD CVDD
C18
0.1u C37 D1 C7 C21 0.1u
3 C158 CR105 27uH C10
DVDD CVDD
C3
C38 DVDD CVDD C22
4700u/6.3V 0.1u R1
DVDD CVDD
F17 0.1u
10uF/20V OS F4
C39 CVDD C23

3
C142 0.1u M18
DVDD CVDD
D15 0.1u C145
C152 R159 C150 J2 D14 10uF/20V OS
U26

4
DVDD CVDD
47uF/16V OS 33k 1000pF 0.1u C40 H18 D11 C24 0.1u
R1224N102H-TR-FA DVDD CVDD
R152 5
U12
DVDD CVDD
L17
0.1u C41 C25 0.1u

EXT
VIN U7 L4
10 DVDD CVDD
C153 R150 U5 K17
3 C42 DVDD CVDD C26
47uF/16V OS VOUT C154 0.1u T3 K4 0.1u
2700 DVDD CVDD
47uF/16V OS

GND
R18 K1
1 C43 DVDD CVDD C27
CE 0.1u W3
DVDD CVDD
U10 0.1u
10uF/20V OS V19 U6
R32 C44 DVDD CVDD C28
SD1 R165 R170 C143 0.1u V15 R17 0.1u C146
10k DVDD CVDD 10uF/20V OS

2
CRS04 1A/40V 15k 330k V13 R4
DVDD CVDD
0.1u C45 U16 L20 C29 0.1u
DVDD CVDD
Y17 V18
+5V C46 DVDD CVDD C30
0.1u Y7
DVDD CVDD
V3 0.1u
W12 U15
C47 DVDD CVDD C31
0.1u W9
DVDD CVDD
U14 0.1u
N1 U11
CVDD C32
W5
Vss CVDD
W19 0.1u
A1 W2
+3.3V Vss CVDD C33
R31 A2
Vss CVDD
A4 0.1u
A11 W1
10K Vss Vss
A14 U20
Vss Vss
A19 U17
C10 0.1u Vss Vss
A20 U13
Vss Vss
Q8 B1 U9
Vss Vss
C12 0.1u HAT1044MWS-E B4 U8
D7 Vss Vss
+1.26V Y20 U4
4 1,2,5,6 L2 RD2.2FB2 1W(DIP) B15
Vss Vss
T4
C75 0.1u Vss Vss
CR105 27uH B20
Vss Vss
P19
C8 P17
Vss Vss
C207 0.1u C9 P4
Vss Vss
D4 N17

3
Vss Vss
D8 N4
C221 0.1u C155 R160 C151 Vss Vss
U27

4
D13 M17
47uF/16V OS 33k 1000pF Vss Vss
PARTS SIDE R1224N102H-TR-FA D17 M4
C222 0.1u R153 5 E2
Vss Vss
K20
VIN EXT Vss Vss
10 E4 K2
C156 R151 Vss Vss
3 E17 J4
C223 0.1u 47uF/16V OS VOUT C157 Vss Vss
2700 F19 H17
47uF/16V OS
GND

Vss Vss
1 G4 H4
CE Vss Vss
C224 0.1u G17 W11
Vss Vss
R33 Y1 W16
SD2 R171 R172 Vss Vss
10k Y2 W20
2

C225 0.1u CRS04 1A/40V 820k 150k Vss Vss

Y13 Y19
Vss Vss
J9 L9
Vss Vss
C226 0.1u +5V J10 L10
Vss Vss
J11 L11
Vss Vss
J12 L12
C227 0.1u Vss Vss
K9 M9
Vss Vss
K10 M10
Vss Vss
C228 0.1u K11 M11
Vss Vss
K12 M12
Vss Vss
C6 T17
C229 0.1u Vss Vss
TMS320C6711CGDP-200
C230 0.1u

C231 0.1u
SOLDER SIDE
C232 0.1u

C233 0.1u
DSP SUPPLY
C234 0.1u

C235 0.1u

C236 0.1u

XK-1

MGH-94A(3/9)
00228-25216
7-3
 XK-1

+5VAN
0.1u C52

8
U7C
NJM4580M
-8V

4
0.1u C51

FSX0

CLKX0
MD
DX0 MC
MS R36 3300
ADMCK C165
U28 PCM1791ADB
MUTE R174 1800 R179 680 560pF
1 28 U7A
LRCK MS
2 27 2
BCK MC C163 R128
+3.3V 3 26 1
DATA MDI 3300pF R178 3 OUT L
4 25 100
MUTE MDO +5VAN
5 24 680 NJM4580M
SCK MSEL R175 1800
C161 6 23 R127
RST ZEROL
10uF/50V C50 R37

10uF/50V
7 22 OUT R
VDD ZEROR C166 100
0.1u 3300

C160
8 21
DGND VCCF C49 560pF
9 20
AGNDF VCCL 0.1u
10 19
VCCR AGNDL
C48 11 18 R38 3300
AGNDR VOUTL-
12 17
13
VOUTR- VOUTL+
16 C167
0.1u VOUTR+ AGNDC
14 15
VCOM VCCC R176 1800 R181 680 560pF
C162 U7B
6
1uF/50V LLA C164
7
3300pF R180 5
R177 1800 680 NJM4580M

R39
C168
3300
560pF

AD/DA SECTION

XK-1

MGH-94A(4/9)
00228-25216
7-4
 XK-1
SLAVE
U30 VASE3 uPD65946GJ-159-JEU
A1 65 94
PIA1 ESCKO
A2 64 95
PIA2 ELRCKO
M_LRCK A3 63
M_LRCK PIA3
M_SCK A4 62 101
M_SCK PIA4 WCLKO
M_DOUT A5 61 100
M_DOUT PIA5 LRCKO
ADMCK A6 60 99
ADMCK PIA6 SCKO
A7 59 98 PK_DOUT
PIA7 DOUT PK_DOUT
A8 58 92 UL_DOUT
PIA8 EXOUT1 UL_DOUT
A9 57 93
PIA9 EXOUT2
A10 56
PIA10
A[0..17] A11 55 96
A[0..17] U29 PIA11 EXIN1
97
A1 65 94 EXIN2
PIA1 ESCKO D0 87
A2 64 95 U32 PID0
PIA2 ELRCKO D1 86 47
A3 63 PWA0 25 29 PWD0 PID1 ADMCK
PIA3 A0 D0 D2 84
A4 62 101 PWA1 24 31 PWD1 PID2
PIA4 WCLKO A1 D1 D3 83
A5 61 100 R57 100 PWA2 23 33 PWD2 PID3
PIA5 LRCKO A2 D2 D4 82
A6 60 99 R76 100 PWA3 22 35 PWD3 PID4
PIA6 SCKO A3 D3 D5 81
A7 59 98 PWA4 21 38 PWD4 PID5
PIA7 DOUT A4 D4 D6 80
A8 58 92 PWA5 20 40 PWD5 PID6
PIA8 EXOUT1 A5 D5 D7 78
A9 57 93 PWA6 19 42 PWD6 PID7
PIA9 EXOUT2 A6 D6
A10 56 PWA7 18 44 PWD7
PIA10 A7 D7 D8 77 51
D[0..15] A11 55 96 UL_DOUT PWA8 8 30 PWD8 PID8 XIN
D[0..15] PIA11 EXIN1 UL_DOUT A8 D8 D9 75
97 PWA9 7 32 PWD9 PID9
EXIN2 A9 D9 D10 74
PWA10 6 34 PWD10 PID10
A10 D10 D11 70
D0 87 47 R91 100 PWA11 5 36 PWD11 PID11 +3.3V
PID0 ADMCK A11 D11 D12 69 50
D1 86 PWA12 4 39 PWD12 PID12 XOUT
PID1 A12 D12 D13 68
D2 84 18 PWA0 PWA13 3 41 PWD13 PID13
PID2 WMA0 A13 D13 D14 67 C62 C63 C61
D3 83 17 PWA1 PWA14 2 43 PWD14 PID14
PID3 WMA1 A14 D14 D15 66 0.1u 0.1u 0.1u
D4 82 16 PWA2 PWA15 1 45 PWD15 PID15
PID4 WMA2 A15 D15/A-1 1
D5 81 15 PWA3 PWA16 48 Vdd
PID5 WMA3 A16 RD 88 36
D6 80 14 PWA4 PWA17 17 47 RD OEn Vdd
PID6 WMA4 A17 BYTE WRH 89 73
D7 78 13 PWA5 PWA18 16 26 WRH WEn Vdd
PID7 WMA5 A18 CE S_VASE_CE 90 108
11 PWA6 PWA19 9 28 S_VASE_CE CEn Vdd
WMA6 A19 OE 53 126
D8 77 10 PWA7 PWA20 10 +3.3V RSTn Vdd C60
PID8 WMA7 A20
D9 75 9 PWA8 PWA21 13 C59 0.1u
PID9 WMA8 A21 SYNC2 48 C170
D10 74 8 PWA9 37 SYNC2 SYNC 0.1u
PID10 WMA9 Vcc C65 45 12
D11 70 7 PWA10 11 +3.3V MTSEL GND
PID11 WMA10 NC 0.1u 46 25
D12 69 6 PWA11 12 27 CHPMD GND
PID12 WMA11 NC GND 50MCLOCK 49 37 1000u/6.3V
D13 68 5 PWA12 14 46 50MCLOCK CKI GND
PID13 WMA12 NC GND 38
D14 67 4 PWA13 15 GND
PID14 WMA13 NC 91 71
D15 66 3 PWA14 TEST GND
PID15 WMA14 133 72
2 PWA15 MR27V6402G(P2ROM64M) TIN GND
WMA15 134 79
RD 88 142 PWA16 (64M ROM 48TSOP) TEN GND
RD OEn WMA16 S_VASE_BUSY 54 85
WRH 89 141 PWA17 S_VASE_BUSY BUSY GND
WRH WEn WMA17 109
M_VASE_CE 90 140 PWA18 GND
M_VASE_CE CEn WMA18 PWA0 18 110
VASE_RESET 53 139 PWA19 WMA0 GND
VASE_RESET RSTn WMA19 PWA1 17 143
138 PWA20 WMA1 GND
WMA20 PWA2 16
SYNC2 48 137 PWA21 WMA2
SYNC2 SYNC WMA21 PWA3 15
45 136 PWA22 R40 WMA3
MTSEL WMA22 PWA4 14 +3.3V
46 135 PWA23 10K WMA4
X2 CHPMD WMA23 U31 PWA5 13 52
49 WMA5 Vdd
1 CKI 32 33 PWD0 PWA6 11
INH 44 PWD0 A0 DQ0 WMA6 C64
+3.3V WMD0 PWA0 28 35 PWD1 PWA7 10 144
PWD1 0.1u
4 FB25 FB26 91 43 A1 DQ1 WMA7 GND
TEST WMD1 PWA1 27 38 PWD2 PWA8 9
VDD 133 42 PWD2 A2 DQ2 WMA8
TIN WMD2 PWA2 26 40 PWD3 PWA9 8
134 41 PWD3 A3 DQ3 WMA9
+3.3V TEN WMD3 PWA3 25 44 PWD4 PWA10 7
54 40 PWD4 A4 DQ4 WMA10
C66 0.1u BUSY WMD4 PWA4 24 46 PWD5 PWA11 6
39 PWD5 A5 DQ5 WMA11
2 WMD5 PWA5 23 49 PWD6 PWA12 5
GND 51 35 PWD6 A6 DQ6 WMA12
XIN WMD6 PWA6 22 51 PWD7 PWA13 4 76
R154 34 PWD7 A7 DQ7 WMA13 NC
3 WMD7 PWA7 20 34 PWD8 PWA14 3
OUT 33 PWD8 A8 DQ8 WMA14
39 WMD8 PWA8 19 36 PWD9 PWA15 2
32 PWD9 A9 DQ9 WMA15
FXO-37FL 50MHz WMD9 PWA9 18 39 PWD10 PWA16 142
50 31 PWD10 A10 DQ10 WMA16
XOUT WMD10 PWA10 17 41 PWD11 PWA17 141
50MCLOCK 30 PWD11 A11 DQ11 WMA17
50MCLOCK WMD11 PWA11 13 45 PWD12 PWA18 140
29 PWD12 A12 DQ12 WMA18
C57 C56 WMD12 PWA12 12 47 PWD13 PWA19 139 131
M_VASE_BUSY 0.1u 0.1u 28 PWD13 A13 DQ13 WMA19 EMD0
M_VASE_BUSY WMD13 PWA13 11 50 PWD14 PWA20 138 130
1 27 PWD14 A14 DQ14 WMA20 EMD1
Vdd WMD14 PWA14 10 52 PWD15 PWA21 137 129
0.1u 36 26 PWD15 A15 DQ15 WMA21 EMD2
+3.3V Vdd WMD15 PWA15 8 PWA22 136 128
C55 73 A16 WMA22 EMD3
Vdd PWA16 7 55 PWA23 135 127
108 24 A17 WE# WMA23 EMD4
Vdd WMOEn PWA17 6 54 125
C169 C54 126 23 A18 OE# EMD5
C53 Vdd WMWEn PWA18 5 16 PWD0 44 124
0.1u 22 A19 RP# WMD0 EMD6
1000u/6.3V WMCS0 PWA19 4 31 PWD1 43 123
21 A20 BYTE# +3.3V WMD1 EMD7
0.1u WMCS1 PWA20 3 53 PWD2 42
12 20 A21 STS WMD2
GND WMCS2 PWA21 1 PWD3 41 122
25 19 A22 WMD3 EMA0
GND WMCS3 PWA22 30 15 PWD4 40 121
37 A23 Vpen +3.3V WMD4 EMA1
GND PWA23 56 43 PWD5 39 120
38 131 NC Vcco WMD5 EMA2
GND EMD0 9 PWD6 35 119
71 130 Vcc WMD6 EMA3
GND EMD1 14 C67 C68 PWD7 34 118
72 129 CE0 WMD7 EMA4
GND EMD2 2 21 0.1u 0.1u PWD8 33 117
79 128 CE1 GND WMD8 EMA5
GND EMD3 29 42 PWD9 32 116
85 127 CE2 GND WMD9 EMA6
GND EMD4 PWD10 31 115
109 125 WMD10 EMA7
GND EMD5 E28F640J3A-120(56TSOP) PWD11 30 114
110 124 WMD11 EMA8
GND EMD6 PWD12 29 113
143
GND EMD7
123 NOT USED PWD13 28
WMD12
WMD13
EMA9
EMA10
112
PWD14 27 111
122 WMD14 EMA11
EMA0 PWD15 26 107
+3.3V 121 WMD15 EMA12
EMA1 106
52 120 EMA13
C58 Vdd EMA2 24 105
119 WMOEn EMA14
0.1u EMA3 23 104
144 118 WMWEnEMA15/ECASN
GND EMA4 22 103
117 WMCS0EMA16/ERASN
EMA5 21
116 WMCS1
EMA6 20 132
115 VASE_RESET WMCS2 EMWEn
EMA7 VASE_RESET 19 102
114 WMCS3 EMTYP +3.3V
EMA8
113
EMA9
112
EMA10
111
EMA11
76 107
NC EMA12
106
EMA13
EMA14
105 XK-1
104
EMA15/ECASN
103
EMA16/ERASN

EMWEn
132 MGH-94A(5/9)
102
EMTYP +3.3V

VASE3 uPD65946GJ-159-JEU
GENERATOR SYSTEM 00228-25216
MASTER
7-5
 XK-1

+3.3V
FB27

X3
1 4 R220 R46
OE VDD
C73 10K
RA6
0.1u U2A U35
8-33
2 3 A3 Y6 5 7 EMD0
GND OUT CLK IN EA2 A0 D0
R221 D7 V7 4 8 EMD1
RSV EA3 A1 D1
SG-636PCE 25MHz Y12 W7 3 9 EMD2
CLKOUT2 EA4 A2 D2
+3.3V C4 V8 2 10 EMD3
NOT USED C5
CLKMODE0 EA5
W8 1
A3 D3
13 EMD4
PLLVH EA6 A4 D4
FB2 A12 Y8 44 14 EMD5
RSV EA7 A5 D5
EXCCET103U C5 +3.3V B5 V9 43 15 EMD6
RSV EA8 A6 D6
C149 0.1u B7 Y9 42 16 EMD7
TMS EA9 A7 D7
10uF/20V OS R49 10K A8 V10 27 29 EMD8
TD0 EA10 A8 D8
D[0..15] A7 W13 26 30 EMD9
D[0..15] TD1 EA11 A9 D9
R48 10K A6 V14 25 31 EMD10
D[0..15] TCK EA12 A10 D10
D[0..15] B6 W14 24 32 EMD11
TRST EA13 A11 D11
D9 Y14 22 35 EMD12
R47 10K B9
EMU0 EA14
W15 21
A12 D12
36 EMD13
EMU1 EA15 A13 D13
D10 Y15 20 37 EMD14
U20 CLKOUT3 EA16 A14 D14
RA11 R42 10K B10 V16 19 38 EMD15
D0 2 18 R229 1500 EMU3 EA17 A15 D15
A0 B0 GSW0 C11 Y16 18
D1 3 17 R230 1500 EMU4 EA18 RA8 8-33 A16
A1 B1 GSW1 B12 W17 23 6
D2 4 16 R231 1500 EMU5 EA19 NC CE
A2 B2 GSW2 R44 10K J19 Y18 +3.3V C72 17
D3 5 15 R232 1500 BUSREQ EA20 0.1u WE
A3 B3 GSW3 J18 U18 11 41
D4 6 14 R233 1500 HOLDA EA21 Vcc OE
A4 B4 GSW4 J17 V17 33 40
D5 7 13 R234 1500 R224 R45 10K HOLD CE0 Vcc UB
A5 B5 GSW5 C13 W18 39
D6 8 12 R235 1500 NMI CE1 LB
A6 B6 GSW6 4700 J20 W6 C71 12
D7 9 11 HINT CE2 GND
A7 B7
+3.3V R223 R52 10K C12
RSV CE3
V6 0.1u 34
GND NC
28
8-100 D12 V11 R41
PIN_CE 19 20 C74 4700 RSV ARE
PIN_CE E Vcc U33 B11 W10 10K RA15 IC62LV12816
1 RSV AOE
DIR 0.1u D0 2 18 E20 V12
10 A0 B0 HD0 AWE
GND D1 3 17 D20 Y5
A1 B1 HD1 ARDY
D2 4 16 D18 Y11
74LV245APW A2 B2 HD2 ECLKIN
D3 5 15 C20 Y10
A3 B3 HD3 ECLKOUT
D4 6 14 C19 V20 4-33
A4 B4 HD4 BE0
D5 7 13 B18 U19 R43 10K
A5 B5 HD5 BE1
+3.3V D6 8 12 C17 Y4
A6 B6 HD6 BE2 RA7
D7

2
9
A7 B7
11 R51 A18
HD7 BE3
V5
8-33
U5B +3.3V A5 K18 EMD0
10K R7 1000 RSV ED0
D12 DSP RESET 3 4 19 20 D3 K19 EMD1

COM
DSP RESET E Vcc R8 1000 EMU2 ED1
+3.3V R54 1SS181 1 L18 EMD2
DIR C70 ED2
4700 74LV04APW 10 R225 R9 1000 N2 L19 EMD3
R53 GND 0.1u RSV ED3
EMD4

2
LES DETECT 4700 C2 M19
74LVC245APW R10 1000 C1
EXT_INT4 ED4
M20 EMD5
4700

3
EXT_INT5 ED5
D13 D2 N18 EMD6

COM
EXT_INT6 ED6
1SS181 U34 E3 N19 EMD7
NOT USED R222
EXT_INT7 ED7
D8 2 18 B17 N20 EMD8
A0 B0 HD8 ED8
D9 3 17 C16 P18 EMD9
A1 B1 HD9 ED9
D10 4 16 B16 P20 EMD10
3

A2 B2 HD10 ED10
D11 5 15 A16 R19 EMD11
A3 B3 HD11 ED11
D12 6 14 C15 R20 EMD12
A4 B4 HD12 ED12
D13 7 13 A15 T18 EMD13
A5 B5 HD13 ED13
D14 8 12 C14 T20 EMD14
A6 B6 HD14 ED14
D15 9 11 B14 T19 EMD15
A7 B7 HD15 ED15
+3.3V K3 V4
ADMCK CLKS0 ED16 RA9
U4D 19 20 H3 W4
12 E Vcc M_SCK CLKR0 ED17 8-33
RD 11 1 J1 Y3
13 DIR C69 M_DOUT DR0 ED18
DSP_CE 10 J3 V2
GND 0.1u M_LRCK FSR0 ED19
74LV32APW E1
CLKS1 ED20
V1
74LVC245APW M1 U2
CLKR1 ED21
R226 M2 U1
DR1 ED22
+3.3V 4700 M3 U3
A[0..17] R50 10K E18
FSR1 ED23
T1
A[0..17] HAS ED24
A4 G20 T2
HR/W ED25
A3 G19 R3
HCNTL1 ED26
A2 G18 R2
HCNTL0 ED27
A1 H20 P1
HHWIL ED28
U3D F20 P2
12 HCS ED29
WRH 11 E19 P3
13 HDS1 ED30
F18 N3
HDS2 ED31 RA4
74LV08APW H19 G3
HRDY CLKX0 CLKX0
A13 H2
RESET DX0 DX0
H1
FSX0 FSX0
F1 L3
TOUT1 CLKX1
F2 L2
PK_DOUT TINP1 DX1 4-100
G1 L1
TOUT0 FSX1
G2
TINP0

+3.3V TMS320C6711CGDP-200
R56
10K

SYSTEM & DSP SECTION

U4E +3.3V
14
VCC
C106
7
GND 0.1u XK-1
74LV32APW

MGH-94A(6/9)
00228-25216
7-6
 XK-1

+3.3V
R155
C171
10 C84
1000u/6.3V 0.1u
R236 FB31

R11 22
J110 Q9 +3.3V
R101 FB28

2
1 U40 1000 2SA1588Y
100pF x 9 RA12
2 1 120 4 5
4' Y0 C76
3 C139 5 10 1 3
2' Y1 A ANSEL0 0.1u NC NC
4 C132 2
1' Y2
5 C133 4 9
1 3/5' Y3 B ANSEL1
6 C134 [FRONT VIEW]
8'
UPPER DRAWBAR 7 C135 12 6 MIDI OUT
16' X0 INH
8 C136 14 C82 U37
1 1/3' X1 FB29
9 C137 15 0.1u 5 2 D2 1SS181 C108
2 2/3' X2 GND NC
10 C138 11
5 1/3' 8-100 X3 2
11 +3.3V MIDI OUT 6

2a
VCC 3 220p
12 16 3 R81 3 COM
NC Vcc Y DRB0 K 1 R102 FB32
C83 4a 5a
R132 0.1u 7 13 330 4 1 1a 3a
B12B-XH-A (LF)(SN) VEE X DRB1 PED MIDI IN OUT A 120 NC NC
C140 100 8
GND C281 C282
PC400V
220p 220p
74LV4052APW LM MIDI IN +3.3V [FRONT VIEW]
D5 1SS181
C77 U36 PEDAL MIDI IN
2
DRB2 0.1u 5 2
GND NC 3
COM C107
1
6
VCC FB33

2b
R82 K
3
FB30 220p
330 4b 5b
4 1
OUT A 1b 3b
R105 NC NC
PC400V 120 C283 C284
220p 220p
[FRONT VIEW]
LM MIDI IN

JACK1 YKF51-5046N

+5V T1 T2 T3
F4052A F4052A F4052A

R228
4700

2
R227

3
4700 +3.3V
D8 R60

COM
1SS184 10K

U38

1
9 1
B Y0
10 5
6
A Y1
2 FOOT SW IN R59
INH Y2 10K 6 JACK3
4
Y3 V BATT 5
FOOTSW_T R103 FB11 4
8 C78
GND 2
EXPIN 3 7 C109 FOOTSW_R 220
EXPIN Y VEE 0.1u
0.1u
R58 3 FOOT SWITCH
16
VCC +3.3V 10K 7
+3.3V R104 FB13 C79 8
12
U39

2
X0 +3.3V 220 9
14 R12 0.1u
X1 14 12 1

3
13 15 COMA AX 220
X X2 13 D3 HLJ2305-01-3010

COM
11 1000 AY FB46
X3 15 R106 1SS181
COMB D9

COM
74LV4052APW R13 1SS184 FB12
4 2 C80
COMC BX R107 JACK2
1000 1 2

3
BY 0.1u
R237 220 3
FOOT VOLUME

1
5 1
CX
3 FB14 HLJ0520-01-010
1M CY C81
11
V PED SEL A
FB47

2
10 16
B VCC +3.3V 0.1u
9
C C110
7 D4

COM
VEE 0.1u
6 8 1SS181
INH GND
74LV4053APW
+3.3V

3
J111 FB45
R19
MIDI OUT JACK
1 100pF x 2
+3.3V 100
2 C260
PITCH PITCH
3 C261
MOD MOD
4
GND R55
B4B-PH-K-S 100

XK-1

MGH-94A(7/9)
00228-25216
7-7
 XK-1
NOT USED
U17
AK0 12 13 DK8
A0 D0
AK1 11 14 DK9
A1 D1
AK2 10 15 DK10
A2 D2
AK3 9 17 DK11 +3.3V
A3 D3
AK4 8 18 DK12
A4 D4
AK5 7 19 DK13
A5 D5
AK6 6 20 DK14 RA17
A6 D6
AK7 5 21 DK15 8-3300
A7 D7
AK8 27 U23
A8
AK9 26 22 H8 CS0 DK8 18 2
A9 CE B0 A0
AK10 23 24 DK9 17 3
A10 OE B1 A1
AK11 25 DK10 16 4
A11 B2 A2
+3.3V AK12 4 +3.3V DK11 15 5
A12 B3 A3
AK13 DK12
NOT USED +3.3V
R62
AK14
28
29
A13
A14
Vpp
1
DK13
14
13
B4
B5
A4
A5
6
7
AK15 3 DK14 12 8
10K AK16
A15
32 C88
B6 A6
2 DK15 11 9
J112 R63 U41 AK17 30
A16 Vcc 0.1u +3.3V
B7 A7
1 10K 12 36 AK0 AK18 31
A17
16 20 19 H8 CS1
+3.3V P90/TXD0 A0 A18/PRG GND Vcc E H8 CS1
2 TXDU1 13 37 AK1 C85 1 H8 HWR
TxDU1 P91/TXD1 A1 DIR H8 HWR
3 14 38 AK2 REA-32DP-32SP 0.1u 10
RxDU1 P92/RXD0 A2 GND
4 RXDU1 15 39 AK3
H8 MD0 H8 MD0 P93/RXD1 A3 74LV245APW
5 40 AK4
H8 MD1 H8 MD1 A4 H8 RD
6 KD0 93 41 AK5
H8 MD2 H8 MD2 PA0/TEND0/TCLKA/TP0 A5
7 KD1 94 42 AK6 U13
RESET KEY RESET/ PA1/TEND1/TCLKB/TP1 A6 RA10
8 KD2 95 43 AK7 AK4 1 15
FWE H8 FWE PA2/TIOCA0/TCLKC/TP2 A7 A Y0
9 KD3 96 AK1 2 14
GND PA3/TIOCB0/TCLKD/TP3 B Y1
10 KD4 97 45 AK8 AK2 3 13
GND PA4/TIOCA1/A23/TP4 A8 C Y2
KD5 98 46 AK9 12
PA5/TIOCB1/A22/TP5 A9 Y3
B10B-PH-K-S KD6 99 47 AK10 11
PA6/TIOCA2/A21/TP6 A10 Y4
KD7 100 48 AK11 AK3 4 10
BOOT CONECT PA7/TIOCB2/A20/TP7 A11 E1 Y5
49 AK12 5 9
A12 E2 Y6
2 50 AK13 6 7
PB0/TMO0/CS7 A13 E3 Y7
3 51 AK14 +3.3V
KEY RXD1 PB1/DREQ0/CS6 A14 8-47
4 52 AK15 16
KEY TXD1
5
PB2/TMO2/CS5 A15 Vcc C86
PB3/DREQ1/CS4 0.1u
KD[0.. 7] 6 53 AK16 H8 CS1 8
KD[0.. 7] PB4/UCAS A16 H8 CS1 GND
7 54 AK17
PB5/LCAS A17
8 55 AK18
PB6/TxD2 A18 74LV138APW
9 56
PB7/RxD2 A19
J114
78
P70/AN0 C263 1 2 FB61
79 18 DK0
P71/AN1 D0 C271 3 4 FB62
80 19 DK1
P72/AN2 D1 C272 5 6 FB63
+3.3V +3.3V 81 20 DK2 +3.3V
P73/AN3 D2 C273 7 8 FB56
82 21 DK3
P74/AN4 D3 47pF x 16 C274 9 10 FB57
83 23 DK4 J113
R65 R66 P75/AN5 D4 C275 11 12 FB58
R64 84 24 DK5 RA16 2 1 C262
10K 10K P76/AN6 D5 C276 13 14 FB59
10K 85 25 DK6 8-3300 4 3 C264
P77/AN7 D6 C277 15 16 FB60
26 DK7 U22 6 5 C265
D7
73 DK0 18 2 FB53 8 7 C266
H8 MD0 MD0 B0 A0 XG4C-1631
74 27 DK8 DK1 17 3 FB54 10 9 C267
H8 MD1 MD1 D8 B1 A1
75 28 DK9 DK2 16 4 FB55 12 11 C268
H8 MD2 MD2 D9 B2 A2 KEYBOARD HI
29 DK10 DK3 15 5 FB48 14 13 C269
TEST11 D10 B3 A3
KEY RESET/ 30 DK11 DK4 14 6 FB49 16 15 C270
D11 B4 A4
63 31 DK12 DK5 13 7 FB50
RESET D12 B5 A5
10 32 DK13 DK6 12 8 FB51 XG4C-1631
R133 RESET OUT D13
33 DK14 DK7 11
B6 A6
9 FB52
KEYSCAN RESET NOT USED D14 B7 A7
100 TEST12 64 34 DK15 +3.3V KEYBOARD LOW
NMI D15
H8 FWE JP6 62 20 19 H8 CS1
H8 FWE +3.3V STBY Vcc E
100 70 H8 RD C87 1 H8 HWR
for Debugger RD DIR H8 HWR
R67 R134 C176 71 H8 HWR 0.1u 10
HWR GND
10K 67
XTAL LWR
72
H8 HWR
66 +3.3V 74LV245APW
10pF X4
EXTAL
69
25MHz AS
C177 61
CLKOUT
88 R61
R135 76
P81/CS3/IREQ1
89 10K
10pF AVcc P82/CS2/IREQ2
100 77 90 H8 CS1
Vref P83/CS1/IREQ3/ADTRG H8 CS1
C89 91 H8 CS0
P84/CS0
0.1u 86
AVss
87 KEYSCAN_CE
P80/IREQ0 KEYSCAN_CE
1 16
+3.3V Vcc P94/IREQ4/SCK0
35 17 U5C
Vcc P95/IREQ5/SCK1
68 5 6
Vcc KEY IREQ
C173 C172 C111
11 74LV04APW
0.1u 0.1u 0.1u Vss
22
Vss
44
Vss
57 58
Vss P60/WAIT
65 59
Vss P61/BREQ
92 60
Vss P62/BACK
HD64F3024F

KEYSCAN CPU

MD0 MD1 MD2 FWE XK-1

Debug(mode 3) 1 1 0 0
On Flash(mode 5) 1 0 1 0
Boot Mode(mode 5) 1 0 0 1 MGH-94A(8/9)
00228-25216
7-8
 XK-1

"LLA" capacitors : Low leakage current

C179 220p

R169
C175
R167 FB3-FB65 : BLM18BD102SN1D
R164 56k
15k 0.01u C184 4700 C209
C195 C180 R69
R70 R162 33k 2 220u/10V
C185 C187 RL1A R156 FB17
10k R71 2 330p 22k U10A
1 2 JACK4
C188 R75 3
OUT L R108 2.2u/50V LLA 220p
2.2u/50V LLA 3 10 3
10k U8A
1 2 4
NJM4556AM HLJ0520-01-010
2.2u/50V LLA 3 1 R137 5 C197 C198
1
220 10k U9A R157 C208 HEAD PHONE
C193 C206 2.2u/50V LLA 3 MAIN Lch 1000p 1000p C203
100 G6S-2 0.1u
1800p NJM4580M 4700p R78 10 FB18 FB19
220u/10V
NJM4580M
C174 10k
R168
R163 56k R74 C178 220p
15k 0.01u C278 J109
C196 10k 100p
R72 R161 33k C181 R166 1
LINEOUT L /MONO
C186 C183 RL1B R183 FB15
10k R73 6 330p R68 2 2
AGND
OUT R 2.2u/50V LLA C189 10 C182 4700 JACK6
7 R109 R77 6 9 22k 6 1000 C200
4 3
LINEOUT R
10k U8B 220p FB64 HLJ0520-01-110
2.2u/50V LLA 5 7 R136 8 7 1000p
1
C194 220 10k U9B U10B B3B-PH-K-S
C205 2.2u/50V LLA 5 2.2u/50V LLA 5 C246 LINEOUT L /MONO
100 G6S-2 0.1u
1800p NJM4580M 4700p NJM4556AM
NJM4580M C199 C279
MAIN Rch 100p
1000p

1
2
3
4
5
6
R182 FB16 2
J115 JACK5
B6B-PH-K-S 1000 4
FB65 1 HLJ0520-01-110 NOT USED

OUT R
OUT L
AGND

AGND
IN R
IN L
C247 LINEOUT R
C216 0.1u
C211 0.1u C280 J102
1000u/6.3V 100p 1
8P ROT IN
8P ROT IN FB22 2
AGND
3
LES DETECT
4
R34 R35 C202 C201 LES SLOW
5
12k 10k 1000p 1000p LES FAST
6
R87 FB20 CHASSIS GND
7
LES DETECT +5VAN

2
100 C215
4 5 FB23 B7B-PH-K-S
0.1u
1 3
+5V
+8V SD3 SD5 +5V 6 7
+5VAN
R85 C214
4700 JACK7
C218 0.1u

8
R86 FB21

E
CRS04 1A/40V CRS04 1A/40V TCS5090-18-4051
100u/16V +5VAN U8C

8
R84 100 LESLIE 8PIN
U42 R239 Q12
U43

8
U10C
LES SLOW 2SC4116GR
1 8 2200 C92 C94 10k
NC NC Q10
1 16 NJM4556AM
2 NC NC 0.1u 0.1u
NC 2SC4116GR
3
NC 2 15
+5V NC NC 0.1u 0.1u

4
R158 C93 C91
-8V
1

7 6
VCC OUT 3 14

4
+ C204
1

10 FB/SD VCC +5V

4
4 5 10u/50V LLA C217 NJM4580M
C190 C191 GND CAP RL1C 4 13 R89
0.1u CAP+ OSC 1000u/6.3V
COM

0.1u U9C 4700

M51953BFP TF1J G6S-2 C210 NJM4580M R90 FB24
5 12
C192 10u/50V LLA GND VREF
POWER ON MUTE +8V 100
- R88 Q13 C213
6 11

8
D10 CAP- VOUT LES FAST 2SC4116GR 0.1u
12
3

10u/50V 1SS181 C212 C90 10k C237 0.1u

7 10 C219
10u/50V LLA NC NC 0.1u
100u/16V
8 9 SD7 C238 0.1u
NC NC CRS04 1A/40V
R240 Q14 PARTS SIDE
AMUTE 2SC4116GR LT1054CDW
4700 C239 0.1u
SD4

C240 0.1u
CRS04 1A/40V C220
SD6 100u/16V
C241 0.1u
CRS04 1A/40V

C242 0.1u
SOLDER SIDE
C243 0.1u

MIXER SECTION C244 0.1u

XK-1

MGH-94A(9/9)
00228-25216
7-9
 XK-1

J201
1 COM0
COM0
2 SW1 SW6
COM1 LED1 LED6
3
COM2
4 D1 D6
COM3
5
COM4
6
GSW0 SOFT PEDAL
7 COM1 SOFT PEDAL
TO MGH-94A GSW1
8 SW2 SW7
GLED0 LED2 LED7
9
GLED1
10 D2 D7
+3.3V
11
O.D.
12
TONE FAST UPPER
13 COM2 FAST UPPER
GND
SW3 SW8 LED3 LED8
S13B-PH-K-S
D3 D8

THIRD REVERB 2
COM3 THIRD REVERB
J202
SW4 SW9 LED4 6 1 3
AG
5
D4 D9 OUT R
4 2'
OUT L
TO MGH-94A IN R
3
SECOND 2 1' 3'
COM4 SECOND TONE IN L
1
SW5 SW10 AG
LED5
S6B-PH-K-S VR1
D5 D10
RK14K12D 5KB
MASTAR VOLUME
LOWER
LOWER CONTROL

GLED0

GLED1
GSW0

GSW1
R2
100

R1

3
100
VR2 VR3
RK11K114 10KB RK11K114 10KB
C1 C2 2 TONE VR 2 O.D VR
0.01u 0.01u 1

PANEL L
SW1-SW10 : SKHVBE
D1-D10 : 1SS133 T-77
LED1-LED8 : L-7104SED(ORANGE) with LED Spacer LDS-90K

XK-1

SWH-510A
00225-42236
7-10
 XK-1

J301
1 GLED4
GLED4
2 GLED3
GLED3
3 GLED2
GLED2
4 GSW5
GSW5
5 GSW4
GSW4
6 GSW3
GSW3
7 GSW2
GSW2
TO MGH-94A COM0
8
9
COM1
10
COM2
11
COM3
12
COM4
13
ROT A
14
ROT B
15
GND
S15B-PH-K-S

DATA VAL
RSW1 A OUT
EC12E24204A9

COM
B OUT COM0
SW1 SW6 SW11 SW16 LED1 LED6 LED11
D1 D6 D11 D16

DEMO PRESET 11 PRESET 3

COM1 DEMO PRESET 11 PRESET 3 MENU/EXIT
SW2 SW7 SW12 SW17 LED2 LED7 LED12
D2 D7 D12 D17

SPLIT PRESET 5 PRESET 8

COM2 SPLIT PRESET 5 PRESET 8 PLAY
SW3 SW8 SW13 SW18 LED3 LED8 LED13
D3 D8 D13 D18

M.BASS PRESET 10 PRESET 2

COM3 M.BASS PRESET 10 PRESET 2 BANK
SW4 SW9 SW14 SW19 LED4 LED9 LED14
D4 D9 D14 D19

ADJUST PRESET 4 PRESET 7

COM4 ADJUST PRESET 4 PRESET 7 REC/JUMP
SW5 SW10 SW15 LED5 LED10 LED15
D5 D10 D15

PRESET 6 PRESET 9 PRESET 1

PRESET 6 PRESET 9 PRESET 1

PANEL R

SW1-SW19 : SKHVBE
D1-D19 : 1SS133 T-77
LED1-LED15 : L-7104SED(ORANGE) with LED Spacer LDS-90K
XK-1

SWH-511A
00225-42241
7-11
 XK-1

J401
1 GSW5
GSW5
2 GLED1
GLED1
3
COM0
4
COM1
5
TO MGH-94A COM2
6
COM3
7
COM4
8 GSW6
GSW6
9 GLED5
GLED5
S9B-PH-K-S

COM0
SW2 LED2
D2

LESLIE ON
COM1 LESLIE ON
SW3 LED3
D3

LESLIE BRAKE
COM2 LESLIE BRAKE
SW4 LED4
D4

CHORUS
COM3 CHORUS
SW5 LED1 LED5
D5

LESLIE FAST V2/C2

COM4 V2/C2
SW1 SW6 LED6
D1 D6

V1/C1
LESLIE FAST V1/C1

ENDBLOCK

SW1-SW6 : SKHVBE
D1-D6 : 1SS133 T-77
LED1-LED6 : L-7104SED(ORANGE) with LED Spacer LDS-80P

XK-1

SWH-512A
00225-42246
7-12
 XK-1

8.PARTS LIST
1 . F I NAL ASS'Y(66710-01101)
2 1

3
3 3
4 4 4 4
3

3
3 4 4 3 4 4 3 3
3

3
3 3 3 3 3 3 3

5
1 Top Panel Ass'y 66710-02101
2 Bottom Panel Ass'y 66710-02201
3 Cross Recessed Tapping Screw Type3 00673-54005
(Binding Head, 4x5, ZnB)
4 Cross Recessed Tapping Screw (For Plastic) 00683-54012
(Binding Head, 4x12, ZnB)
5 Lithium Batteries (CR2032) 00357-01009

2 . T O P PANEL ASS'Y(66710-02101)

1 3

9
6 10

(Side view)

4 10 5 10
7 8

8-1
XK-1

1 Top Panel 00451-40549 7 WR-HZ133-E 00443-01350

2 Top Board 00450-40719 8 WR-HZ133-B 00443-01347
3 LCD Cover 00452-40198 9 Cross Recessed Tapping Screw Type1 00615-53008
4 Switch Board L Ass'y 66710-02103 (Binding Head, 3x8, ZnY)
5 Switch Board R Ass'y 66710-02104 10 Cross Recessed Tapping Screw Type3 00673-53005
6 LCD Unit HZ-133 Ass'y 66710-02106 (Binding Head, 3x5, ZnB)

22 24 16
23 25 21 16
22 15
15
20
14 19 19
20

24 24

13
16

17 18
18 17

11 12

11 Side Board L Ass'y 66710-02202 19 Machine Screw 00703-23012

12 Side Board R Ass'y 66710-02203 (Oval Countersunk Head, M3x12, ZnB)
13 Endblock L Ass'y 66710-02102 20 Serrated Toothed Flange Nut(M3, ZnY) 00725-83000
14 WR-HZ133-G 00443-01352 21 Cap Square Neck Bolt(M4x12, A1, ZnB) 00713-64012
15 WR-HZ133-H 00443-01353 22 Hexagon Nut(M4, ZnY) 00725-14000
16 Cross Recessed Tapping Screw Type2 00653-54008 23 Toothed Lock Washer(Btype, 4, ZnY) 00755-44000
(Fluted Point)(Binding Head, 4x8, ZnB) 24 Cross Recessed Tapping Screw Type3 00673-53005
17 Machine Screw 00703-24010 (Binding Head, 3x5, ZnB)
(Oval Countersunk Head, M4x10, ZnB) 25 Plain Washer(5x12x1, ZnB) 00743-25000
18 Rosette Washer(5x14x3, ZnB) 00750-04002

8-2
 XK-1

33 27

29

34

28 28
34 26 34

33

31
36 33 37 36 33 36
32 33

27

33 33 33 35 33 35 30
33

26 Top Panel Bracket 00451-40553 34 Cross Recessed Tapping Screw Type2 00653-33005
27 Main Board Bracket 00451-40556 (Fluted Point)(Flat Head, 3x5, ZnB)
28 Jack Bracket 00451-40586 35 Cross Recessed Tapping Screw 00683-53008
29 MGH-94A Ass'y 00228-25216 (For Plastic)(Binding Head, 3x8, ZnB)
30 Switching Power Supply 00366-01015 36 Machine Screw 00703-53006
31 Ferrite Core 00362-01017 (Binding Head, M3x6, ZnB)
32 Fixture For Ferrite Core 00362-01018 37 Nylon Rivet(P3045BLK) 00760-03003
33 Cross Recessed Tapping Screw Type3 00673-53005
(Binding Head, 3x5, ZnB) 43 42

41 38 41 41

39 41 40 40

38 KEYBOARD 00277-15001 41 Cross Recessed Tapping Screw(For Plastic) 00683-54012

39 WR-HZ133-A 00443-01346 (Binding Head, 4x12, ZnB)
40 WR-HZ133-J 00443-01354 42 Knob #1 00452-40199
43 Knob #2 (With White Line) 00452-40200

8-3
XK-1

3 . E N D B L OCK L ASS'Y(66710-02102)

10

2
4

10

1
6

10

1 Endblock L 00452-40203 8 Cross Recessed Tapping Screw Type2 00655-53025

2 Switch Board EL Ass'y 66710-02105 (Fluted Point)(Binding Head, 3x25, ZnY)
3 WR-HZ133-C 00443-01348 9 Cross Recessed Tapping Screw 00683-54012
4 Wheel Ass'y 66710-02107 (For Plastic)(Binding Head, 4x12, ZnB)
5 Endblock Bracket L1 00451-40554 10 Cross Recessed Tapping Screw 00683-53006
6 Endblock Bracket L2 00451-40555 (For Plastic)(Binding Head, 3x6, ZnB)
7 Drawbar Ass'y DB-609A 00278-51001

4 . S W I T C H BOARD L ASS'Y(66710-02103)

1 SWH-510A Ass'y 00225-42236

2 Keytop #1 00452-40205
3 Keytop #2-K 00452-40206
1 3 3 2

8-4
 XK-1

5. S W I T C H BOARD R ASS'Y (66710-02104)

2
3

1 SWH-511A Ass'y 00225-42241

2 Keytop #2-K 00452-40206
3 Keytop #2-R 00452-40207

6 . S W I T CH BOARD EL ASS 'Y(66710-0215)

1 SWH-512A Ass'y 00225-42246

2 Keytop #1 00452-40205

7 . B O T T OM PANEL ASS'Y( 66710-02201)

2
2

1 Bottom Panel 00451-40550

2 Plastic Foot 00453-40028
1

8 . S I D E BOARD L ASS'Y(6 6710-02202)

2 3 1

1 Side Bracket L 00452-40203

2 Side Board L 66710-02105
3 Cross Recessed Tapping Screw Type1 66710-02105
(Truss Head, 4x16, ZnY)

8-5
XK-1

9 . S ID E B O A RD R ASS'Y(66710-02203)

1 Side Bracket R 00451-40552

4 1 2 2 SIde Board R 00450-40718
3 3 Endblock R 00452-40204
4 Cross Recessed Tapping Screw type1 00615-64016
(Truss head, 4x16, ZnY)
5 Cross Recessed Tapping Screw for plastic 00683-54012
6 (Binding Head, 4x12, ZnB)
5
6 Cross Recessed Tapping Screw type1 00615-53012
(Binding Head, 3x12, ZnY)

1 0 . AC C E S S O RY

1 User's Manual(Japanese) 00457-40112

1
User's Manual(English) 00457-40113
2 AC Cord 100V(3m) 00439-02002
AC Cord 120V(3m) 00439-01004

2
AC Cord 220V(3m) 00439-01005
AC Cord 4622-001-0403 00439-01033
AC Cord 240V(3m) 00439-01006

8-6
 XK-1
9.DISASSEMBLING PROCEDURE
CAUTION:First,Disconnect ORGAN from A.C.source.

1.DISMOUNT THE BOTTOM PANEL = A

= B

Remove the 19 screws(Cross recessed tapping screw type3,

Bind,4x5,ZnB) A from the bottom panel.

Remove the 8 screws(Cross recessed tapping screw for plastic,

Bind,4x12,ZnB) B from the bottom panel.

2.DISMOUNT THE KEYBOARD

C D D C
Remove the 4 screws(Cross recessed tapping screw for plastic,
Bind,4x12,ZnB) C from the bottom panel. C C

Remove the 2 Wiring(WR-HZ33-J) D .

After that, Remove the Keyboard from the bottom panel.

3.DISMOUNT THE KEYBOARD

Remove the 9 screws(Cross recessed tapping screw

F F F
for plastic ,Bind,3x5,ZnB) E from the Main board BKT.

Remove the 3 screws(Cross recessed tapping screw

E E E
type2,Flat,3x5,ZnB) F from the top panel BKT.

Remove the 3 screws(Machine screw,Bind,M3x6,ZnB) G I

E E
and Remove the 2 screws(Cross recessed tapping screw G G H H
G
for plastic, Bind,3x8,ZnB) H from MGH-94A Ass'y.

The rivet I is pushed out from the back. E E E E

4.DISMOUNT THE ENDBLOCK (L)

J J

Remove the 2 screws(Cross recessed tapping screw type3, K

Bind,3x5,ZnB) J from the endblock(L).

Remove the 1 screws(Cross recessed tapping screw type2,

fluted point,Bind,4x8,ZnB) K from the bottom panel.

9
 XK-1
10.WARNING

WARNING

Bat t ery R eplac ement

Repl ac e bat t er y wi t h S ON Y or HITACHI MAXELL or

SHENZHEN GAONENGDA BATTERY CO.,LTD

P ar t No . CR2032 On l y .
Use o f an o t h er bat t er y m ay pr esen t a r i sk o f fi r e o r expl o si o n .

Bat t er y m ay expl o de i f m i st r eat ed.

Do n o t r ec h ar ge, di sassem bl e.

Co l l ec t u sed bat t er y pr o m pt l y .
K eep away fr o m c h i l der n .
Do n o t di sassem bl e an d do n o t di spo se i n fi r e.

Battery

MGH-94A

10
11. XK-1 Technical description

1. Switching power supply (JRC AES10-5)

This board commutates the AC power input and supplies +5V
power. This +5V power is used as a MGH-94A’s power source.

2. Main, CPU, VASE, DSP and JACK on the board MGH-94A

2 CPUs, 2 VASE3s (sound generator), DSP, D/A converter and
jacks are all built in the MGH-94A. The Main CPU and the VASE 3
simulate the tone wheel generator and the multi-contact keying to
provide the effects.

2-1.Main CPU
The U1 means the Main CPU (SH7144). This CPU communicates to
the switch scan, each switch’s operation, the LCD display, the
analog-digital conversion for drawbars and volume, the VASE3, the
DSP control and the SUB CPU.

2-2. SUB CPU

The U41 means the SUB CPU (3024). This CPU does key-scan and
communicates with the Main CPU.

2-3. Main memory

Main soft wear is stored at the 16bit flash memory of the U14
(29LV160CBTC). The U15 and U44, 1Mbit SRAM is supplied VCC by
a battery and saves the each parameter. It is also used for a
workspace.

2-4. System reset

The U11 constantly monitors +3.3V and tells the Main CPU to reset
when the voltage is reduced. This circuit helps to switch the back
up SRAM power to the battery(BT1) at the same time.

2-5. VASE3 sound generator

The U29 and 30 is a sound generator LSI and each one has 64
simultaneous tones (Total is 128 tones). 96 out of 128 tones are
 used for UM and LM tone wheel generator and the rest are used
for pedal, percussion and key-click. It switches off the tone wheel
channel when the extra voice is selected.
It also reads the data of U32 wave ROM and outputs the key
sound which was ordered by the Main CPU, to DSP.

2-6 DSP
The U2, TMS320C6711CGDP is the high efficient DSP, which has a
internal clock (200MHz). The memory for the delay system is the
U35, 1M SRAM. This DSP has a chorus vibrato, overdrive, tone
control, expression control, Leslie simulation, reverbs and delay
system.

2-7 D/A converter

The U28 is the high efficient D/A converter, which has a 24 bit
balanced output system. The U7, OPAMP, which is behind the D/A
converter, converts the balanced signal to the unbalanced one and,
at the same time, work as the LOWPASS FILTER which gets out
the SAMPLING CLOCK.

2-8 Serial Interface

PK MIDI IN, LM MIDI IN and MIDI OUT are connected to the U1,
Main CPU (SH7144) directly.

2-9 LCD control

The U1, Main CPU controls the LCD display (2 lines x 20 letters).

3. Panel Switch board SWH-510A, 511A, 512A

Each of them is connected to the MGH-94A and controlled by the
U1, Main CPU (SH7144).

SWH-510 has the VR1 (master volume), VR2 (tone volume) and
VR3 (overdrive volume). And it is connected to the MGH-94A. The
tone volume has a center click.
SWH-511 has the RSW1 (rotary encorder) and is connected to the
MGH-94A.
12. Initialization and checking the soft-wear versions

1. Initialization
Please follow the below procedure to initialize the XK-1.

a. Turn off the power of the XK-1.

b. Turn on the power again with pressing the [REC/JUMP] button.
c. Keep pressing the [REC/JUMP] button till the screen shows
“Loading Default …”.
d. When the initialization is completed, the play mode appears on
the display screen.

2. Check the soft-wear versions

Please follow the below procedure to check the XK-1 soft-wear
version number.

a. Turn on the XK-1.

b. From the play mode screen, select a [MENU/EXIT] button and
see the screen changes to the MENU. Select the page “D” from
page button.
c. Press [4] SYSTEM button and the Main Program appears on the
screen.
d. Press [>] button and the tone information appears on the
screen.
e. Press [>] button and the Demo songs appears on the screen.
f. Press [>] button and the Key scan program appears on the
screen.
g. Press [>] button and the Boot program appears on the screen.