N.

B Calculation is made on Infinitue Bus Method

Fault Current Calculation Jignesh.Parmar www.jiguparmar.com

Fault Current at Transformer Primary Side (Enter This Value if You know otherwise leave blank)

Fault Current At Transformer

Transformer Kva 3
Secondary Voltage of Transformer (Line-Line) 433
Secondary Voltage of Transformer (Line-Neutral) 250
Transformer Impedance (Zt) 6
Transformer Secondary Full Load Current I (Line-Line) 4
Transformer Secondary Full Load Current I (Line-Neutral) 6
KVA Short Circuit At Primary Side
Source Impedance (Zu) 0.0000
Total Impedance (Z =Zu+Zt) 0.0600
Short Circuit Current RMS Symmetrical 67
Fault Current At Transformer Secondary ( Isc(L-L)=I (L-L)/Total Impedance) 67
Fault Current At Transformer Secondary ( Isc(L-N)=I (L-N)/Total Impedance) 100
Fault Current At Main Panel
Cable Length from Transformer to Main Panel 50
Type of Cable Cu
No of Conductor/Phase 1
Size of Phase Conductor 120 mm2
Size of Neutral Conductor 120 mm2
Type of Race Way Non-Metalic
Phase Conductor Constant (C1) 17483
Neutral Conductor Constant (C2) 17483
F1(L-L) [F(L-L)=(1.732 X Length X Isc)/(C1 X No of Conductor X Volt)] 0.001
F2(L-N) [F(L-L)=(1.732 X Length X Isc)/(C2 X No of Conductor X Volt)] 0.002
M1(L-L) [M=(1/(1+F1)] 0.999
M2(L-N) [M=(1/(1+F2)] 0.998
Fault Current at Main Panel Disconnection (L-L) [Isc X M1] 67
Fault Current at Main Panel Disconnection (L-N) [Isc X M2] 100
Fault Current At Sub Panel
Cable Length from Main Panel to Sub Panel 20
Type of Cable Cu
No of Conductor/Phase 1
Size of Phase Conductor 30 mm2
Size of Neutral Conductor 127 mm2
Type of Race Way Non-Metalic
Phase Conductor Constant (C1) 4833
Neutral Conductor Constant (C2) 19779
F1(L-L) [F(L-L)=(1.732 X Length X Isc)/(C1 X No of Conductor X Volt)] 0.001
F2(L-N) [F(L-L)=(1.732 X Length X Isc)/(C2 X No of Conductor X Volt)] 0.000
M1(L-L) [M=(1/(1+F1)] 0.999
M2(L-N) [M=(1/(1+F2)] 1.000
Fault Current at Sub Panel Disconnection (L-L) [Isc X M1] 67
Fault Current at Sub Panel Disconnection (L-N) [Isc X M2] 100
Fault Current At Distribution Board
Cable Length from Sub Panel to Distribution Board 50
Type of Cable Cu
No of Conductor/Phase 1
Size of Phase Conductor 127 mm2
Size of Neutral Conductor 127 mm2
Type of Race Way Non-Metalic
Phase Conductor Constant (C1) 18594
Neutral Conductor Constant (C2) 18594
F1(L-L) [F(L-L)=(1.732 X Length X Isc)/(C1 X No of Conductor X Volt)] 0.001
F2(L-N) [F(L-L)=(1.732 X Length X Isc)/(C2 X No of Conductor X Volt)] 0.001
M1(L-L) [M=(1/(1+F1)] 0.999
M2(L-N) [M=(1/(1+F2)] 0.999
Fault Current at Distribution Board Disconnection (L-L) [Isc X M1] 66
Fault Current at Distribution Board Disconnection (L-N) [Isc X M2] 100
h.Parmar www.jiguparmar.com

Amp Alu 1 Core Cable Non-Metalic

Cu 3 Core Cable Metalic
Yes
Kva No
Volt
Volt
%
Amp
Amp

Amp
Amp
Amp

Meter
3 Core Cable

Amp
Amp

Meter
3 Core Cable

Amp
Amp

Meter
1 Core Cable
Amp
Amp
 Fault Current Calculation Jignesh.Parm

Calculating Fault Current From Power Generation From Power Distribution T/C

Fault Level at Incoming Site 360 MVA

Base MVA (For H.T beaker and Transformer Primary side) 3 MVA
Base KV (For H.T beaker and Transformer Primary side) 11 KV
Base KV (For Transformer Secondary,LT Panel,D.B) 0.433 KV

Fault Level at HT Sub Station Side

P.U Reactance at Incoming of H.T Breaker [Z p.u(A) ] 0.008 Ω

Fault Level at Diesel / Gas Generator

Size of Cable from Generator To H.T Sub Station HT XLPE ( 6.6 KV-Earthed) CU 1cX25
Length of Cable from Generator To H.T Sub Station 100 Meter
R (D.G) 1.100 Ω/Km
X (D.G) 0.129 Ω/Km
R (D.G) 0.110 Ω
X (D.G) 0.013 Ω
Z P.U (B) 0.111 Ω
Total Z p.u (Z p.u(A) + Z p.u(B) 0.119 Ω
Fault Level at H.T Side Diesel / Gas Generator 25.19 MVA

Fault Level at Transformer Side

Transformer Rating 1.5 MVA
Transformer Impedance 6.5 %
Size of Cable from H.T Breaker To Transformer HT XLPE ( 11 KV-Earthed) CU 3cX 400
Length of Cable from H.T Breaker To Transformer 100 Meter
R (T/C) 0.102 Ω/Km
X (T/C) 0.097 Ω/Km
R (T/C) 0.010 Ω
X (T/C) 0.010 Ω
Z(T/C) 0.014 Ω
Z p.u (C) 0.000 Ω
Total Z p.u (D) (Up to Transformer Primary) 0.119 Ω
Fault Level at Transformer Primary Side 25.12 MVA
% Reactance at Base KVA 6.500 %
Z P.U (T/C) 0.065 Ω
Total P.U Impedance up to T/C Secondary 0.184 Ω
Fault Level at Transformer Secondary Side 8.13 MVA
Fault Current at Transformer Secondary 10.84 Kamp
Fault Level at LT Sub Station Side
Fault Level at Main LT Panel Side
Size of Cable from Transformer To Main LT Panel LT XLPE (Up to 1.1 KV) CU 3cX 95
Length of Cable from Transformer To Main LT Panel 100 Meter
R (Main LT) 0.247 Ω/Km
X (Main LT) 0.074 Ω/Km
R (Main LT) 0.025 Ω
X (Main LT) 0.007 Ω
Z (D) 0.026 Ω
Z p.u (D) 0.206 Ω
Total Z p.u (D) (Up to LT Main Panel) 0.326 Ω
Fault Level at Main LT Panel 4.61 MVA
Fault Current at Main LT Panel 6.14 Kamp
 Fault Level at LT Sub Panel Side
Size of Cable from Main LT Panel To LT Sub Panel LT XLPE (Up to 1.1 KV) CU 3.5X50
Length of Cable from Main LT Panel To LT Sub Panel 100 Meter
R (LT Sub) 0.050 Ω/Km
X (LT Sub) 0.078 Ω/Km
R (LT Sub) 0.005 Ω
X (LT Sub) 0.008 Ω
Z (E) 0.009 Ω
Z p.u (E) 0.074 Ω
Total Z p.u (D) (Up to LT Sub Panel) 0.400 Ω
Fault Level at LT Sub Panel 3.75 MVA
Fault Current at LT Sub Panel 5.00 Kamp

Fault Level at Distribution Board Side

Size of Cable from LT Sub Panel To Distribution Board PVC Flexible (Up to 1.1 KV) CU 1cX4
Length of Cable from LT Sub Panel To Distribution Board 100 Meter
R (Distribution Board) 4.950 Ω/Km
X (Distribution Board) 0.000 Ω/Km
R (Distribution Board) 0.495 Ω
X (Distribution Board) 0.000 Ω
R (Distribution Board) 0.495 Ω
Z p.u (F) 3.960 Ω
Total Z p.u (F) (Up to Distribution Board) 4.122 Ω
Fault Level at Distribution Board 0.36 MVA
Fault Current at Distribution Board 0.49 Kamp
Jignesh.Parmar www.jiguparmar.com [email protected]

Calculation Results
Fault Level at Incoming Site 360 MVA
Fault Level at H.T Side Diesel / Gas Generator 25.19 MVA
Fault Level at Transformer Primary Side 25.12 MVA
Fault Level at Transformer Secondary Side 8.13 MVA
Fault Current at Transformer Secondary 10.84 Kamp
Fault Level at Main LT Panel 4.61 MVA
Fault Current at Main LT Panel 6.14 Kamp
Fault Level at LT Sub Panel 3.75 MVA
Fault Current at LT Sub Panel 5.00 Kamp
Fault Level at Distribution Board 0.36 MVA
1 Runs Fault Current at Distribution Board 0.49 Kamp

N.B: Calculation is based on Base KVA Method

1 Runs

Ω/Km
Ω/Km

1 Runs

Ω/Km
Ω/Km
1 Runs

Ω/Km
Ω/Km

1 Runs

Ω/Km
Ω/Km
PVC Flexible (Up to 1.1 KV)
LT PVC (Up to 1.1 KV) 1cX25 1cX 95 1cX4 1cX0.5
LT XLPE (Up to 1.1 KV) 1cX35 1cX120 1cX6 1cX0.75
HT XLPE ( 6.6 KV-Earthed) 1cX50 1cX150 1cX10 1cX1
HT XLPE ( 11 KV-Earthed) 1cX70 1cX185 1cX16 1cX1.5
HT XLPE ( 11 KV-Un Earthed) 1cX95 1cX240 1cX25 1cX2.5
HT XLPE ( 66 KV-Earthed) 1cX120 1cX300 1cX35 1cX4
AL 1cX150 1cX400 1cX50 1cX6
CU 1cX185 1cX 500 1cX70 1cX10
1 1cX240 1cX 630 1cX95 1cX16
1cX300 1cX800 1cX120 1cX25
1cX400 1cX1000 1cX150 1cX35
1cX 500 1cX185 1cX50
1cX 630 1cX240 1cX70
1cX800 1cX300 1cX95
1cX1000 1cX400 1cX120
3cX 25 1cX 500 2cX0.5
3cX 35 1cX 630 2cX0.75
3cX 50 1cX800 2cX1
3cX 70 1cX1000 2cX1.5
3cX 95 2cX1.5 2cX2.5
3cX 120 2cX2.5 2cX4
3cX 150 2cX4 3cX0.5
3cX 185 2cX 6 3cX0.75
3cX 240 2cX10 3cX1
3cX 300 2cX16 3cX1.5
3cX 400 2cX25 3cX2.5
2cX35 3cX4
2cX50
2cX70
2cX95
2cX120
2cX150
2cX185
2cX240
2cX300
2cX400
2cX500
2cX630
3cX1.5
3cX2.5
3cX4
3cX 6
3cX 10
3cX 16
3cX 25
3cX 35
3cX 50
3cX 70
3cX 95
3cX 120
3cX 150
3cX 185
3cX 240
3cX 300
3cX 400
3cX 500
3cX 630
3.5X16
3.5X25
3.5X35
3.5X50
3.5X70
3.5X95
3.5X120
3.5X150
3.5X185
3.5X240
3.5X300
3.5X400
3.5X500
3.5X630
4cX 1.5
4cX 2.5
4cX4
4cX 6
4cX 10
4cX16
4cX 25
4cX35
4cX 50
4cX70
4cX 95
4cX 120
4cX 150
4cX 185
4cX 240
4cX 300
4cX 400
4cX 500
4cX 630
 "C" For Copper conductor.
3 Single Conductor 3 Conductor Cable
mm2 AWG/Kcmill
600V 600V
Steel Nonmagnetic Steel Nonmagnetic
2.5 mm2 14 AWG 389 389 389 389
4 mm2 12 AWG 617 617 617 617
6 mm2 10 AWG 981 982 982 982
10 mm2 8 AWG 1557 1559 1559 1560
16 mm2 6 AWG 2425 2430 2431 2433
25 mm2 4 AWG 3806 3826 3830 3838
30 mm2 3 AWG 4774 4811 4820 4833
35 mm2 2 AWG 5907 6044 5989 6087
50 mm2 1 AWG 7293 7493 7454 7579
55 mm2 O AWG 8925 9317 9210 9473
70 mm2 OO AWG 10755 11424 11245 11703
95 mm2 OOO AWG 12844 13923 13656 14410
120 mm2 OOOO AWG 15082 16673 16392 17483
127 mm2 250 kcmil 16483 18594 18311 19779
152 mm2 300 kcmil 18177 20868 20617 22525
177 mm2 350 kcmil 19704 22737 22646 24904
203 mm2 400 kcmil 20566 24297 24253 26916
253 mm2 500 kcmil 22185 26706 26980 30096
304 mm2 600 kcmil 22965 28033 28752 32154
355 mm2 750 kcmil 24137 29735 31051 34605
507 mm2 1000 kcmil 25278 31491 33864 37197
Cu
Non-Metalic 120 mm2 15082 16673 16392 17483
3 Core Cable 120 mm2 15082 16673 16392 17483
0 0 0 17483
0 0 0 17483

Cu
Non-Metalic 30 mm2 4774 4811 4820 4833
3 Core Cable 127 mm2 16483 18594 18311 19779
0 0 0 4833
0 0 0 19779

Cu
Non-Metalic 127 mm2 16483 18594 18311 19779
1 Core Cable 127 mm2 16483 18594 18311 19779
0 18594 0 0
0 18594 0 0
 "C" For Allu conductor.
3 Single Conductor 3 Conductor Cable
mm2 AWG/Kcmill
600V 600V
Steel Nonmagnetic Steel Nonmagnetic
2.5 mm2 14 AWG 237 237 237 237
4 mm2 12 AWG 376 376 376 376
6 mm2 10 AWG 599 599 599 599
10 mm2 8 AWG 951 952 952 952
16 mm2 6 AWG 1481 1482 1482 1482
25 mm2 4 AWG 2346 2350 2351 2353
30 mm2 3 AWG 2952 2961 2963 2966
35 mm2 2 AWG 3713 3730 3734 3740
50 mm2 1 AWG 4645 4678 4686 4699
55 mm2 O AWG 5777 5838 5852 5876
70 mm2 OO AWG 7187 7301 7327 7373
95 mm2 OOO AWG 8826 9110 9077 9243
120 mm2 OOOO AWG 10741 11174 11185 11409
127 mm2 250 kcmil 12122 12862 12797 13236
152 mm2 300 kcmil 13910 14923 14917 15495
177 mm2 350 kcmil 15484 16813 16795 17635
203 mm2 400 kcmil 16671 18506 18462 19588
253 mm2 500 kcmil 18756 21391 21395 23018
304 mm2 600 kcmil 20093 23451 23633 25708
355 mm2 750 kcmil 21766 25976 26432 29036
507 mm2 1000 kcmil 23478 28779 29865 32938

10741 11174 11185 11409

10741 11174 11185 11409
0 0 0 0 17483
0 0 0 0 17483

2952 2961 2963 2966

12122 12862 12797 13236
0 0 0 0 4833
0 0 0 0 19779

12122 12862 12797 13236

12122 12862 12797 13236
0 0 0 0 18594
0 0 0 0 18594
 PVC Flexible
Nominal Maximum Maximum Aluminium Copper Copper
Conductor Area Conductor Conductor Current Current Current
(Sq.mm) Resistance Reactance Carrying Carrying Carrying
at 20°C at 20°C Capacity (Amp) Capacity Capacity
(ohm/km) (ohm/km) (Amp) (Amp)
1cX0.5 39 0 4 4 0.057
1cX0.75 26 0 7 7 0.100
1cX1 19.5 0 11 11 0.157
1cX1.5 13.3 0 15 15 0.214 HT XLPE ( 6.6 KV-Earthed)
1cX2.5 7.98 0 19 19 0.271 1cX25
1cX4 4.95 0 26 26 0.371 CU
1cX6 3.3 0 35 35 0.500 2
1cX10 1.91 0 46 46 0.657
1cX16 1.21 0 62 62 0.886
1cX25 0.78 0 80 80 1.143
1cX35 0.554 0 102 102 1.457
1cX50 0.386 0 138 138 1.971
1cX70 0.272 0 214 214 3.057
1cX95 0.206 0 254 254 3.629
1cX120 0.161 0 300 300 4.286
2cX0.5 39 0 4 4 0.057 PVC Flexible (Up to 1.1 KV)
2cX0.75 26 0 7 7 0.100 LT PVC (Up to 1.1 KV)
2cX1 19.5 0 11 11 0.157 LT XLPE (Up to 1.1 KV)
2cX1.5 13.3 0 15 15 0.214 HT XLPE ( 6.6 KV-Earthed)
2cX2.5 7.98 0 19 19 0.271 HT XLPE ( 11 KV-Earthed)
2cX4 4.95 0 26 26 0.371 HT XLPE ( 11 KV-Un Earthed)
3cX0.5 39 0 4 4 0.057 HT XLPE ( 66 KV-Earthed)
3cX0.75 26 0 7 7 0.100
3cX1 19.5 0 11 11 0.157
3cX1.5 13.3 0 15 15 0.214
3cX2.5 7.98 0 19 19 0.271 HT XLPE ( 6.6 KV-Earthed)
3cX4 4.95 0 26 26 0.371
HT XLPE ( 11 KV-Earthed)
3cX 400
CU
2

PVC Flexible (Up to 1.1 KV)

LT PVC (Up to 1.1 KV)
LT XLPE (Up to 1.1 KV)
HT XLPE ( 6.6 KV-Earthed)
HT XLPE ( 11 KV-Earthed)
HT XLPE ( 11 KV-Un Earthed)
HT XLPE ( 66 KV-Earthed)
 HT XLPE ( 11 KV-Earthed)

LT XLPE (Up to 1.1 KV)

3cX 95
CU
2

PVC Flexible (Up to 1.1 KV)

LT PVC (Up to 1.1 KV)
LT XLPE (Up to 1.1 KV)
HT XLPE ( 6.6 KV-Earthed)
HT XLPE ( 11 KV-Earthed)
HT XLPE ( 11 KV-Un Earthed)
HT XLPE ( 66 KV-Earthed)

LT XLPE (Up to 1.1 KV)

LT XLPE (Up to 1.1 KV)

3.5X50
CU
2

PVC Flexible (Up to 1.1 KV)

LT PVC (Up to 1.1 KV)
LT XLPE (Up to 1.1 KV)
HT XLPE ( 6.6 KV-Earthed)
HT XLPE ( 11 KV-Earthed)
HT XLPE ( 11 KV-Un Earthed)
HT XLPE ( 66 KV-Earthed)

LT XLPE (Up to 1.1 KV)

PVC Flexible (Up to 1.1 KV)

1cX4
CU
2
 PVC Flexible (Up to 1.1 KV)
LT PVC (Up to 1.1 KV)
LT XLPE (Up to 1.1 KV)
HT XLPE ( 6.6 KV-Earthed)
HT XLPE ( 11 KV-Earthed)
HT XLPE ( 11 KV-Un Earthed)
HT XLPE ( 66 KV-Earthed)

PVC Flexible (Up to 1.1 KV)

2 3 4 5 6 7
Nominal 1.1 KV PVC Insulated
Conductor Area
Aluminium Copper Aluminum
(Sq.mm)
Resi React Resi React Ground Duct
ohm/km ohm/km ohm/km ohm/km Amp Amp
1cX4 8.8 0.158 5.52 0.0158 — —
1cX6 5.53 0.148 3.69 0.148 39 37
1cX10 3.7 0.138 2.19 0.138 51 51
1cX16 2.29 0.128 1.38 0.128 66 65
1cX25 1.44 0.12 0.87 0.12 86 84
1cX35 1.04 0.114 0.627 0.114 100 100
1cX50 0.77 0.11 0.463 0.11 120 115
1cX70 0.53 0.103 0.321 0.103 140 135
1cX95 0.38 0.101 0.231 0.101 175 155
1cX120 0.3 0.096 0.184 0.096 195 170
1cX150 0.25 0.094 0.149 0.094 220 190
1cX185 0.2 0.092 0.12 0.092 240 210
1cX240 0.15 0.09 0.091 0.09 270 225
1cX300 0.12 0.088 0.074 0.088 295 245
1cX400 0.094 0.088 0.059 0.088 325 275
1cX 500 0.0726 0.087 0.046 0.087 345 295
1cX 630 0.0563 0.086 0.037 0.086 390 320
1cX800 0.044 0.083 0.031 0.083 450 380
1cX1000 0.0349 0.082 0.027 0.082 500 415
2cX1.5 21.72 0.126 14.5 0.126 18 16
2cX2.5 14.52 0.119 8.87 0.119 16 21
2cX4 8.89 0.116 5.52 0.116 32 27
2cX 6 5.53 0.11 3.69 0.11 40 34
2cX10 3.7 0.1 2.19 0.1 55 45
2cX16 2.29 0.097 1.38 0.097 70 58
2cX25 1.44 0.097 0.87 0.097 90 76
2cX35 1.04 0.097 0.627 0.097 110 92
2cX50 0.77 0.094 0.463 0.094 135 115
2cX70 0.53 0.09 0.321 0.09 160 140
2cX95 0.38 0.09 0.231 0.9 190 170
2cX120 0.3 0.087 0.184 0.087 210 190
2cX150 0.25 0.087 0.149 0.087 240 210
2cX185 0.2 0.087 0.12 0.087 275 240
2cX240 0.15 0.087 0.091 0.087 320 275
2cX300 0.12 0.086 0.073 0.086 355 305
2cX400 0.09 0.086 0.059 0.086 385 345
2cX500 0.09 0.086 0.059 0.086 425 380
 2cX630 0.09 0.086 0.059 0.086 465 415
3cX1.5 21.72 0.126 14.5 0.126 16 14
3cX2.5 14.52 0.119 8.87 0.119 21 18
3cX4 8.89 0.116 5.52 0.116 28 23
3cX 6 5.53 0.11 3.69 0.11 35 30
3cX 10 3.7 0.1 2.19 0.1 46 39
3cX 16 2.29 0.097 1.38 0.097 60 50
3cX 25 1.44 0.097 0.87 0.097 76 63
3cX 35 1.04 0.097 0.627 0.097 92 77
3cX 50 0.77 0.094 0.463 0.094 110 95
3cX 70 0.53 0.09 0.321 0.09 135 115
3cX 95 0.38 0.9 0.231 0.09 165 140
3cX 120 0.3 0.087 0.184 0.087 185 155
3cX 150 0.25 0.087 0.149 0.087 210 175
3cX 185 0.2 0.087 0.12 0.087 235 200
3cX 240 0.15 0.087 0.0912 0.087 275 235
3cX 300 0.12 0.086 0.0739 0.086 305 260
3cX 400 0.09 0.086 0.0592 0.086 335 290
3cX 500 0.09 0.086 0.0592 0.086 370 320
3cX 630 0.09 0.086 0.0592 0.086 405 350
3.5X16 1.44 0.097 0.73 0.097 70 65
3.5X25 0.77 0.094 0.387 .0.094 76 63
3.5X35 0.53 0.09 0.268 0.09 92 77
3.5X50 0.38 0.09 0.193 0.09 110 95
3.5X70 0.3 0.087 0.153 0.087 135 115
3.5X95 0.2 0.087 0.099 0.087 165 140
3.5X120 0.15 0.087 0.075 0.087 185 155
3.5X150 0.12 0.086 0.06 0.086 210 175
3.5X185 0.09 0.086 0.047 0.086 235 200
3.5X240 0.08 0.085 0.046 0.085 275 235
3.5X300 0.08 0.085 0.046 0.085 305 260
3.5X400 0.08 0.084 0.045 0.084 335 290
3.5X500 0.08 0.084 0.045 0.084 370 320
3.5X630 0.08 0.084 0.045 0.084 405 350
4cX 1.5 21.72 0.126 14.5 0.126 16 14
4cX 2.5 14.52 0.119 8.87 0.119 21 18
4cX4 8.89 0.116 5.52 0.116 28 23
4cX 6 5.53 0.11 3.69 0.11 35 30
4cX 10 3.7 0.1 2.19 0.1 46 39
4cX16 2.29 0.097 1.38 0.097 60 50
4cX 25 1.44 0.097 0.87 0.097 76 63
4cX35 1.04 0.097 0.62 0.097 92 77
4cX 50 0.77 0.094 0.46 0.094 110 95
4cX70 0.53 0.09 0.32 0.09 135 115
4cX 95 0.38 0.9 0.23 0.09 165 140
4cX 120 0.3 0.087 0.18 0.087 185 155
4cX 150 0.25 0.087 0.14 0.087 210 175
4cX 185 0.2 0.087 0.12 0.087 235 200
4cX 240 0.15 0.087 0.091 0.087 275 235
4cX 300 0.12 0.086 0.073 0.086 305 260
4cX 400 0.09 0.086 0.059 0.086 335 290
4cX 500 0.09 0.086 0.059 0.086 370 320
4cX 630 0.09 0.086 0.059 0.086 405 350

Nominal 3.8 / 6.6 KV(6.6 KV Earthed) AL/COPPER COND, XLPE INS

Conductor Area Aluminium Copper Aluminum
(Sq.mm) Resi React Resi React Ground Duct
ohm/km ohm/km ohm/km ohm/km Amp Amp
1cX25 1.1 0.129 1.1 0.129 100 90
 1cX35 1.1 0.129 1.1 0.129 120 105
1cX50 0.822 0.1293 0.822 0.1293 140 125
1cX70 0.568 0.1195 0.568 0.1195 175 155
1cX95 0.411 0.113 0.411 0.113 205 180
1cX120 0.325 0.1085 0.325 0.1085 235 205
1cX150 0.265 0.1062 0.265 0.1062 260 230
1cX185 0.211 0.1025 0.211 0.1025 295 260
1cX240 0.161 0.1011 0.161 0.1011 340 300
1cX300 0.13 0.0988 0.13 0.0988 385 335
1cX400 0.102 0.0959 0.102 0.0959 0.57 440
1cX 500 0.08 0.0936 0.08 0.0936 0.60 495
1cX 630 0.063 0.0919 0.063 0.0919 0.67 560
1cX800 0.0513 0.0895 0.0513 0.0895 0.76 620
1cX1000 0.0426 0.0875 0.0426 0.0875 0.82 680
3cX 25 1.1 0.134 1.1 0.134 95 82
3cX 35 1.1 0.134 1.1 0.134 115 97
3cX 50 0.822 0.1358 0.822 0.1358 130 115
3cX 70 0.568 0.1237 0.568 0.1237 160 140
3cX 95 0.411 0.1168 0.411 0.1168 190 165
3cX 120 0.325 0.1128 0.325 0.1128 220 190
3cX 150 0.265 0.1096 0.265 0.1096 245 210
3cX 185 0.211 0.1073 0.211 0.1073 275 240
3cX 240 0.161 0.1041 0.161 0.1041 315 275
3cX 300 0.13 0.1002 0.13 0.1002 355 310
3cX 400 0.102 0.0968 0.102 0.0968 400 350

Nominal 6.6 /11 KV(6.6KV Un-Earthed/11KV Earthed) AL/COPPER COND, X

Conductor Area Aluminium Copper Aluminum
(Sq.mm) Resi React Resi React Ground Duct
ohm/km ohm/km ohm/km ohm/km Amp Amp
1cX25 1.1 0.134 1.1 0.134 100 90
1cX35 1.1 0.134 1.1 0.134 120 105
1cX50 0.822 0.1358 0.822 0.1358 140 125
1cX70 0.568 0.1237 0.568 0.1237 175 155
1cX95 0.411 0.1168 0.411 0.1168 205 180
1cX120 0.325 0.1128 0.325 0.1128 235 205
1cX150 0.265 0.1096 0.265 0.1096 260 230
1cX185 0.211 0.1073 0.211 0.1073 295 260
1cX240 0.161 0.1041 0.161 0.1041 340 300
1cX300 0.13 0.1002 0.13 0.1002 385 335
1cX400 0.102 0.0968 0.102 0.0968 440 380
1cX 500 0.08 0.0939 0.08 0.0939 495 430
1cX 630 0.063 0.0921 0.063 0.0921 560 480
1cX800 0.0513 0.097 0.0513 0.097 620 530
1cX1000 0.0426 0.0875 0.0426 0.0875 680 580
3cX 25 1.1 0.134 1.1 0.134 95 82
3cX 35 1.1 0.134 1.1 0.134 115 97
3cX 50 0.822 0.1358 0.822 0.1358 130 115
3cX 70 0.568 0.1237 0.568 0.1237 160 140
3cX 95 0.411 0.1168 0.411 0.1168 190 165
3cX 120 0.325 0.1128 0.325 0.1128 220 190
3cX 150 0.265 0.1096 0.265 0.1096 245 210
3cX 185 0.211 0.1073 0.211 0.1073 275 240
3cX 240 0.161 0.1041 0.161 0.1041 315 275
3cX 300 0.13 0.1002 0.13 0.1002 355 310
3cX 400 0.102 0.0968 0.102 0.0968 400 350
 Nominal 11 KV(11KV Un Earthed) AL/COPPER COND, XLPE INSU
Conductor Area Aluminium Copper Aluminum
(Sq.mm) Resi React Resi React Ground Duct
ohm/km ohm/km ohm/km ohm/km Amp Amp
1cX25 1.1 0.134 1.1 0.134 100 90
1cX35 1.1 0.134 1.1 0.134 120 105
1cX50 0.822 0.1358 0.822 0.1358 140 125
1cX70 0.568 0.1237 0.568 0.1237 175 155
1cX95 0.411 0.1168 0.411 0.1168 205 180
1cX120 0.325 0.1128 0.325 0.1128 235 205
1cX150 0.265 0.1096 0.265 0.1096 260 230
1cX185 0.211 0.1073 0.211 0.1073 295 260
1cX240 0.161 0.1041 0.161 0.1041 340 300
1cX300 0.13 0.1002 0.13 0.1002 385 335
1cX400 0.102 0.0968 0.102 0.0968 440 380
1cX 500 0.08 0.0939 0.08 0.0939 495 430
1cX 630 0.063 0.0921 0.063 0.0921 560 480
1cX800 0.0513 0.097 0.0513 0.097 620 530
1cX1000 0.0426 0.0875 0.0426 0.0875 680 580
3cX 25 1.1 0.134 1.1 0.134 95 82
3cX 35 1.1 0.134 1.1 0.134 115 97
3cX 50 0.822 0.1358 0.822 0.1358 130 115
3cX 70 0.568 0.1237 0.568 0.1237 160 140
3cX 95 0.411 0.1168 0.411 0.1168 190 165
3cX 120 0.325 0.1128 0.325 0.1128 220 190
3cX 150 0.265 0.1096 0.265 0.1096 245 210
3cX 185 0.211 0.1073 0.211 0.1073 275 240
3cX 240 0.161 0.1041 0.161 0.1041 315 275
3cX 300 0.13 0.1002 0.13 0.1002 355 310
3cX 400 0.102 0.0968 0.102 0.0968 400 350

Nominal 66 KV(66 KV Un Earthed) AL/COPPER COND, XLPE INSU

Conductor Area Aluminium Copper Aluminum
(Sq.mm) Resi React Resi React Ground Duct
ohm/km ohm/km ohm/km ohm/km Amp Amp
1cX 95 0.32 0.219 195 240
1cX120 0.253 0.218 220 280
1cX150 0.206 0.217 240 335
1cX185 0.164 0.215 275 380
1cX240 0.125 0.2 320 450
1cX300 0.1 0.19 360 510
1cX400 0.778 0.181 410 595
1cX 500 0.0605 0.183 460 690
1cX 630 0.0469 0.183 525 800
1cX800 0.0367 0.183 590 910
1cX1000 0.0291 0.183 650 1010
 PVC Flexible (Up to 1.1 KV)
LT PVC (Up to 1.1 KV)
LT XLPE (Up to 1.1 KV)
HT XLPE ( 6.6 KV-Earthed)
HT XLPE ( 11 KV-Earthed)
HT XLPE ( 11 KV-Un Earthed)
HT XLPE ( 66 KV-Earthed)

AL CU S.C
Rsi React Amp Amp
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0
1.1 0.129 0 130 3.58
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0

1.1 0.129 130 3.58

0

AL CL S.C
Rsi React Amp Amp
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0
0.102 0.0968 0 500 57.20
0 0 0 0 0
0 0 0 0 0
0.102 0.0968 500 57.20

PVC Flexible (Up to 1.1 KV)

LT PVC (Up to 1.1 KV)
LT XLPE (Up to 1.1 KV)
HT XLPE ( 6.6 KV-Earthed)
HT XLPE ( 11 KV-Earthed)
HT XLPE ( 11 KV-Un Earthed)
HT XLPE ( 66 KV-Earthed)

AL CL S.C
Rsi React Amp Amp
0 0 0 0 0
0 0 0 0 0
0.247 0.074 0 250 13.59
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0

0.247 0.074 250 13.59

PVC Flexible (Up to 1.1 KV)

LT PVC (Up to 1.1 KV)
LT XLPE (Up to 1.1 KV)
HT XLPE ( 6.6 KV-Earthed)
HT XLPE ( 11 KV-Earthed)
HT XLPE ( 11 KV-Un Earthed)
HT XLPE ( 66 KV-Earthed)

AL CL S.C
Rsi React Amp Amp
0 0 0 0 0
0 0 0 0 0
0.0495 0.078 0 170 7.15
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0

0.0495 0.078 170 7.15

PVC Flexible (Up to 1.1 KV)

LT PVC (Up to 1.1 KV)
LT XLPE (Up to 1.1 KV)
HT XLPE ( 6.6 KV-Earthed)
HT XLPE ( 11 KV-Earthed)
HT XLPE ( 11 KV-Un Earthed)
HT XLPE ( 66 KV-Earthed)
 AL CU S.C
Rsi React Amp Amp
4.95 0 26 26 0.371428571428571
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0
0 0 0 0 0

4.95 0 26 0.371428571428571

8 9 10 11 12 13 14 15
1.1 KV PVC Insulated
num Copper Short Circuit Current Rating for 1Sec.duration
Aluminium
in K. Amps
Air Ground Duct Air Resi React
Aluminium Copper
Amp Amp Amp Amp ohm/km ohm/km
— 39 38 35 0.304 0.460 1.555 0.102
35 49 48 44 0.456 0.690 1.553 0.102
47 65 64 60 0.760 1.150 1.553 0.102
64 85 83 82 1.220 1.84 1.54 0.102
84 110 110 110 1.900 2.88 1.54 0.102
105 130 125 130 2.660 4.03 1.11 0.097
130 155 150 165 3.800 5.75 0.82 0.092
155 190 175 205 5.320 8.05 0.56 0.088
190 220 200 245 7.220 10.90 0.41 0.085
220 250 220 280 9.120 13.80 0.32 0.082
250 280 245 320 11.40 17.30 0.265 0.082
290 305 260 370 14.10 21.30 0.211 0.082
335 345 285 425 18.20 27.30 0.162 0.079
380 375 310 475 22.80 34.50 0.13 0.078
435 400 335 550 30.40 46.00 0.1023 0.077
480 425 355 590 38.00 57.50 0.0808 0.076
550 470 375 660 47.90 72.50 0.0648 0.075
610 530 425 725 60.80 92.00 0.053 0.075
680 590 740 870 76.00 115.00 0.0444 0.068
16 23 20 20 0.3 0.4 — —
21 32 27 27 0.3 0.4 — —
27 41 35 35 0.304 0.460 1.555 0.097
35 50 44 45 0.456 0.690 1.553 0.097
47 70 58 60 0.760 1.150 1.553 0.085
59 90 75 78 1.220 1.840 1.54 0.08
78 115 97 105 1.900 2.880 1.54 0.08
99 140 120 125 2.660 4.030 1.11 0.08
125 165 145 155 3.800 5.750 0.082 0.078
150 205 180 195 5.320 8.050 0.57 0.077
185 240 215 230 7.220 10.90 0.41 0.074
210 275 235 265 9.120 13.80 0.33 0.072
240 310 270 305 11.40 17.300 0.27 0.072
275 350 300 350 14.10 21.280 0.21 0.072
325 405 345 410 18.20 27.600 0.16 0.072
365 450 385 465 22.80 34.500 0.13 0.071
420 490 485 530 30.40 46.000 0.1 0.07
475 540 460 605 38.00 57.500 0.1 0.07
 540 640 550 785 47.90 72.550 0.1 0.07
13 21 17 17 0.3 0.4 — —
18 27 24 24 0.3 0.4 — —
23 36 30 30 0.304 0.460 1.581 0.097
30 45 38 39 0.456 0.690 1.57 0.097
40 60 50 52 0.760 1.150 1.55 0.08
51 77 64 66 1.220 1.840 1.557 0.08
70 99 81 90 1.900 2.880 1.54 0.08
86 120 99 110 2.660 4.030 1.11 0.08
105 145 125 135 3.800 5.750 0.082 0.078
130 175 150 165 5.320 8.050 0.57 0.077
155 210 175 200 7.220 10.900 0.41 0.074
180 240 195 230 9.120 13.800 0.33 0.072
205 270 225 265 11.40 17.300 0.27 0.072
240 300 255 305 14.10 21.300 0.21 0.072
280 345 295 355 18.20 27.600 0.16 0.072
315 385 335 400 22.80 34.500 0.13 0.071
375 425 360 435 30.40 46.000 0.1 0.07
425 470 390 520 38.00 57.500 0.1 0.07
480 555 470 675 47.90 72.500 0.1 0.07
62 99 81 90 1.8 2.5 — —
70 99 81 90 1.90 2.88 1.54 0.08
86 120 99 110 2.66 4.03 1.11 0.08
105 145 125 135 3.80 5.75 0.082 0.078
130 175 150 165 5.32 8.05 0.57 0.077
155 210 175 200 7.22 10.90 0.41 0.074
180 240 195 230 9.12 13.80 0.33 0.072
205 270 225 265 11.40 17.30 0.27 0.072
240 300 255 305 14.10 21.30 0.21 0.072
280 345 295 355 18.20 27.60 0.16 0.072
315 385 335 400 22.80 34.50 0.13 0.071
375 425 360 435 30.40 46.00 0.1 0.07
425 470 390 520 38.00 57.50 0.1 0.07
480 555 470 675 47.90 72.50 0.1 0.07
13 21 17 17 0.3 0.4 — —
18 27 24 24 0.3 0.4 — —
23 36 30 30 0.304 0.460 5.53 0.11
30 45 38 39 0.456 0.690 3.7 0.1
40 60 50 52 0.760 1.150 2.29 0.097
51 77 64 66 1.220 1.840 2.45 0.08
70 99 81 90 1.900 2.880 1.54 0.08
86 120 99 110 2.660 4.030 1.11 0.08
105 145 125 135 3.800 5.750 0.082 0.078
130 175 150 165 5.320 8.050 0.57 0.077
155 210 175 200 7.220 10.900 0.41 0.074
180 240 195 230 9.120 13.800 0.33 0.072
205 270 225 265 11.400 17.300 0.27 0.072
240 300 255 305 14.100 21.300 0.21 0.072
280 345 295 355 18.200 27.600 0.16 0.072
315 385 335 400 22.800 34.500 0.13 0.071
375 425 360 435 30.400 46.000 0.1 0.07
425 470 390 520 38.000 57.500 0.1 0.07
480 555 470 675 47.900 72.500 0.1 0.07

d) AL/COPPER COND, XLPE INSULATED CABLES

num Copper Short Circuit Current Rating for 1Sec.duration
in K. Amps
Air Ground Duct Air
Aluminium Copper
Amp Amp Amp Amp
120 130 115 155 2.35 3.58
 145 155 140 185 3.29 5.00
170 185 160 220 4.70 7.15
215 225 195 275 6.58 10.01
260 265 235 340 8.93 13.59
305 300 265 390 11.28 17.16
345 335 295 440 14.10 21.45
395 380 330 510 17.39 26.46
470 435 380 600 22.56 34.32
540 490 425 680 28.20 42.90
380 630 550 480 790 37.60
430 730 610 530 910 47.00
480 840 680 580 1030 59.22
530 960 740 630 1140 75.20
580 1070 790 670 1250 94.00
105 120 105 135 2.35 3.58
125 145 125 165 3.29 5.01
150 170 150 195 4.70 7.15
190 210 180 240 6.58 10.01
230 250 215 295 8.93 13.59
260 280 240 335 11.28 17.16
295 310 270 380 14.10 21.45
335 350 305 430 17.39 26.46
395 400 350 500 22.56 34.32
450 445 390 570 28.20 42.90
520 500 440 650 37.60 57.20

V Earthed) AL/COPPER COND, XLPE INSULATED CABLES

num Copper Short Circuit Current Rating for 1Sec.duration
in K. Amps
Air Ground Duct Air
Aluminium Copper
Amp Amp Amp Amp
120 130 115 155 2.35 3.58
145 155 140 185 3.29 5.00
170 185 160 220 4.70 7.15
215 225 195 275 6.58 10.01
260 265 235 340 8.93 13.59
305 300 265 390 11.28 17.16
345 335 295 440 14.10 21.45
395 380 330 510 17.39 26.46
470 435 380 600 22.56 34.32
540 490 425 680 28.20 42.90
630 550 480 790 37.60 57.20
730 610 530 910 47.00 71.50
840 680 580 1030 59.22 90.10
960 740 630 1140 75.20 114.40
1070 790 670 1250 94.00 143.00
105 120 105 135 2.35 3.58
125 145 125 165 3.29 5.01
150 170 150 195 4.70 7.15
190 210 180 240 6.58 10.01
230 250 215 295 8.93 13.59
260 280 240 335 11.28 17.16
295 310 270 380 14.10 21.45
335 350 305 430 17.39 26.46
395 400 350 500 22.56 34.32
450 445 390 570 28.20 42.90
520 500 440 650 37.60 57.20
 AL/COPPER COND, XLPE INSULATED CABLES
num Copper Short Circuit Current Rating for 1Sec.duration
in K. Amps
Air Ground Duct Air
Aluminium Copper
Amp Amp Amp Amp
120 130 115 155 2.35 3.58
145 155 140 185 3.29 5.00
170 185 160 220 4.70 7.15
215 225 195 275 6.58 10.01
260 265 235 340 8.93 13.59
305 300 265 390 11.28 17.16
345 335 295 440 14.10 21.45
395 380 330 510 17.39 26.46
470 435 380 600 22.56 34.32
540 490 425 680 28.20 42.90
630 550 480 790 37.60 57.20
730 610 530 910 47.00 71.50
840 680 580 1030 59.22 90.10
960 740 630 1140 75.20 114.40
1070 790 670 1250 94.00 143.00
105 120 105 135 2.35 3.58
125 145 125 165 3.29 5.01
150 170 150 195 4.70 7.15
190 210 180 240 6.58 10.01
230 250 215 295 8.93 13.59
260 280 240 335 11.28 17.16
295 310 270 380 14.10 21.45
335 350 305 430 17.39 26.46
395 400 350 500 22.56 34.32
450 445 390 570 28.20 42.90
520 500 440 650 37.60 57.20

) AL/COPPER COND, XLPE INSULATED CABLES

num Copper Short Circuit Current Rating for 1Sec.duration
in K. Amps
Air Ground Duct Air
Aluminium Copper
Amp Amp Amp Amp
240 9.8
280 12.4
335 15.5
380 19.2
450 24.8
510 31.1
595 41.4
690 51.8
800 65.2
910 82.8
1010 104
 Corrrection Factor:K1 Ground Corrrection Factor:K2 Corrrection Factor:K3
Ambient Insulation Ground Insulation Soil Thermal Resistivity: 2.5 k.m/W
Temp© PVC XLPE/EPR Temp© PVC XLPE/EPR Resistivity K3
10 1.22 1.15 10 1.1 1.07 1 1.18
15 1.17 1.12 15 1.05 1.04 1.5 1.1
20 1.12 1.08 20 0.95 0.96 2 1.05
25 1.06 1.04 25 0.89 0.93 2.5 1
35 0.94 0.96 35 0.77 0.89 3 0.96
40 0.87 0.91 40 0.71 0.85
45 0.79 0.87 45 0.63 0.8 Corrrection Factor:K3
50 0.71 0.82 50 0.55 0.76 Nature of Soil K3
55 0.61 0.76 55 0.45 0.71 Very Wet Soil 1.21
60 0.5 0.71 60 0 0.65 Wet Soil 1.13
65 0 0.65 65 0 0.6 Damp Soil 1.05
70 0 0.58 70 0 0.53 Dry Soil 1
75 0 0.5 75 0 0.46 Very Dry Soil 0.86
80 0 0.41 80 0 0.38
 16 17 18 19 20 21 22 23
1.1 KV XLPE Insulated
Copper Aluminum Copper
Resi React Ground Duct Air Ground Duct Air
ohm/km ohm/km Amp Amp Amp Amp Amp Amp
1.555 0.102 — — — 48 47 45
1.553 0.102 48 45 45 60 59 57
1.553 0.102 62 62 61 80 78 77
1.54 0.102 81 80 83 104 102 106
0.93 0.102 99 90 115 130 115 145
0.671 0.097 117 110 135 155 140 175
0.495 0.092 138 125 170 185 165 215
0.343 0.088 168 155 210 225 200 270
0.247 0.085 204 185 255 265 235 330
0.196 0.082 230 210 300 300 265 380
0.159 0.082 265 230 342 335 300 430
0.127 0.082 295 260 385 380 335 495
0.0965 0.079 340 300 450 435 385 590
0.0769 0.078 390 335 519 490 430 670
0.0608 0.077 450 380 605 550 480 780
0.0468 0.076 500 430 700 610 530 900
0.0362 0.075 555 485 809 680 590 1020
0.0283 0.075 625 530 935 740 630 1140
0.0225 0.068 690 570 1065 780 660 1250
— — — — — — — —
— — — — — — — —
1.555 0.097 34 28 30 44 37 39
1.553 0.097 43 37 40 55 47 50
1.553 0.085 57 48 53 74 61 67
1.54 0.08 78 61 70 94 78 85
0.93 0.08 95 80 99 120 100 125
0.671 0.08 116 94 117 145 120 155
0.495 0.078 140 110 140 170 145 190
0.343 0.077 170 140 176 210 175 235
0.247 0.074 200 165 221 250 210 290
0.196 0.072 225 185 258 285 240 330
0.159 0.072 255 210 294 315 270 375
0.127 0.072 285 235 339 355 300 435
0.0965 0.072 325 270 402 410 350 510
0.0769 0.071 370 305 461 460 390 590
0.0602 0.07 435 350 542 520 440 670
0.0602 0.07 481 405 624 580 480 750
0.0602 0.07 537 470 723 680 575 875
— — — — — — — —
— — — — — — — —
1.581 0.097 34 28 30 44 37 39
1.57 0.097 43 37 40 55 47 50
1.55 0.08 57 48 53 74 61 67
1.557 0.08 78 61 70 94 78 85
0.93 0.08 95 80 99 120 100 125
0.671 0.08 116 94 117 145 120 155
0.495 0.078 140 110 140 170 145 190
0.343 0.077 170 140 176 210 175 235
0.247 0.074 200 165 221 250 210 290
0.196 0.072 225 185 258 285 240 330
0.159 0.072 255 210 294 315 270 375
0.127 0.072 285 235 339 355 300 435
0.0965 0.072 325 270 402 410 350 510
0.0769 0.071 370 305 461 460 390 590
0.0602 0.07 435 350 542 520 440 670
0.0602 0.07 481 405 624 580 480 750
0.0602 0.07 537 470 723 680 575 875
— — — — — — — —
0.93 0.08 95 80 99 120 100 125
0.671 0.08 116 94 117 145 120 155
0.0495 0.078 140 110 140 170 145 190
0.343 0.077 170 140 176 210 175 235
0.247 0.074 200 165 221 250 210 290
0.196 0.072 225 185 258 285 240 330
0.159 0.072 255 210 294 315 270 375
0.127 0.072 285 235 339 355 300 435
0.0965 0.072 325 270 402 410 350 510
0.0769 0.071 370 305 461 460 390 590
0.0602 0.07 435 350 542 520 440 670
0.0602 0.07 481 405 624 580 480 750
0.0602 0.07 537 470 723 680 575 875
— — — — — — — —
— — — — — — — —
3.69 0.11 34 28 30 44 37 39
2.19 0.1 43 37 40 55 47 50
1.38 0.097 57 48 53 74 61 67
1.47 0.08 78 61 70 94 78 85
0.93 0.08 95 80 99 120 100 125
0.671 0.08 116 94 117 145 120 155
0.495 0.078 140 110 140 170 145 190
0.343 0.077 170 140 176 210 175 235
0.247 0.074 200 165 221 250 210 290
0.196 0.072 225 185 258 285 240 330
0.159 0.072 255 210 294 315 270 375
0.127 0.072 285 235 339 355 300 435
0.0965 0.072 325 270 402 410 350 510
0.0769 0.071 370 305 461 460 390 590
0.0602 0.07 435 350 542 520 440 670
0.0602 0.07 481 405 624 580 480 750
0.0602 0.07 537 470 723 680 575 875
 Correction Factor(K4)(Ground Cable Dist) No of (Grouping factor)==
No of Circuit Nill cable Dia 0.125m 0.25m 0.5m Cable/Tray 1 2
1 1 1 1 1 1 1 1 1
2 0.75 0.8 0.85 0.9 0.9 2 0.84 0.8
3 0.65 0.7 0.75 0.8 0.85 3 0.8 0.76
4 0.6 0.6 0.7 0.75 0.8 4 0.78 0.74
5 0.55 0.55 0.65 0.7 0.8 5 0.77 0.73
6 0.5 0.55 0.6 0.7 0.8 6 0.75 0.71
7 0.74 0.69
(Temp. Derating factor) 8 0.73 0.69
PVC Flexible
LT PVC LT XLPE HT XLPE Depth Facator (K5)
(Up to 1.1 KV)
1 25 1.25 1.16 1.28 1.14 Laying Depth(mt) Rating Factor
2 30 1.16 1.1 1.22 1.1 0.5 1.1
3 35 1.09 1.05 1.134 1.04 0.7 1.05
4 40 1 1 1 1 0.9 1.01
5 45 0.9 0.94 0.975 0.95 1 1
6 50 0.8 0.88 0.878 0.9 1.2 0.98
7 55 0.69 0.82 0.768 0.85 1.5 0.96
8 60 0.62 0.74 0.658 0.8
 24 25

Short Circuit Current Rating

for 1Sec.duration in K. Amps

Aluminium Copper

0.376 0.572
0.564 0.858
0.940 1.430
1.504 2.288
2.350 3.575
3.290 5.005
4.700 7.150
6.580 10.01
8.930 13.59
11.28 17.16
14.10 21.45
17.39 26.46
22.56 34.32
28.20 42.90
37.60 57.20
47.00 71.50
59.22 90.09
75.20 114.40
94.00 143.00
— —
— —
0.376 0.572
0.564 0.858
0.940 1.430
1.50 2.29
2.35 3.58
3.29 5.01
4.70 7.15
6.58 10.01
8.93 13.59
11.28 17.16
14.10 21.45
17.39 26.46
22.56 34.32
28.20 42.90
37.60 57.20
47.00 71.50
59.22 90.09
— —
— —
0.376 0.572
0.564 0.858
0.940 1.430
1.50 2.29
2.35 3.58
3.29 5.01
4.70 7.15
6.58 10.01
8.93 13.59
11.28 17.16
14.10 21.45
17.39 26.46
22.56 34.32
28.20 42.90
37.60 57.20
47.00 71.50
59.22 90.09
— —
2.35 3.58
3.29 5.01
4.70 7.15
6.58 10.01
8.93 13.59
11.28 17.16
14.10 21.45
17.39 26.46
22.56 34.32
28.20 42.90
37.60 57.20
47.00 71.50
59.22 90.09
— —
— —
0.376 0.572
0.564 0.858
0.940 1.430
1.50 2.29
2.35 3.58
3.29 5.01
4.70 7.15
6.58 10.01
8.93 13.59
11.28 17.16
14.10 21.45
17.39 26.46
22.56 34.32
28.20 42.90
37.60 57.20
47.00 71.50
59.22 90.09
(Grouping factor)==No of Tray
3 4 6 8
1 1 1 1
0.78 0.77 0.76 0.75
0.74 0.73 0.72 0.71
0.72 0.71 0.7 0.69
0.7 0.69 0.68 0.67
0.7 0.68 0.68 0.66
0.675 0.66 0.66 0.64
0.68 0.67 0.66 0.64