Features

1. For low temperature condition: -50℃ to 0℃.

2. Low starting and running torques particularly at low temperatures

Pack sizes Basic properties

HIWIN G07
Consistency enhancer Lithium-calcium soap
Color Beige
Basic oil Mineral
Service temperature range (℃) -50 to 80
NLGI Grade 1
Viscosity (cst/40℃) 14
Origin Germany
1. Identification of the substance/mixture and of the company/undertaking
Product details
Trade name: HIWIN G07
Application of the substance / the preparation: Grease
Manufacturer/Supplier: HIWIN TECHNOLOGIES CORP.
No.7, Jingke Road, Taichung Precision Machinery Park, Taichung 40852, Taiwan
Tel.: +886-4-23594510 Fax: +886-4-23594420
Information in case of emergency: +886-4-23594510

2. Hazards identification
Classification of the substance or mixture
Classification (REGULATION (EC) No 1272/2008)
Not a hazardous substance or mixture.
Classification (67/548/EEC, 1999/45/EC)
Not a hazardous substance or mixture.
Label elements
Labelling (REGULATION (EC) No 1272/2008)
Not a hazardous substance or mixture.
Additional Labelling:
EUH210 Safety data sheet available on request.
Other hazards

3. Composition/information on ingredients
Mixtures
Chemical nature:
Mineral oil.
lithium calcium soap
Hazardous components

Chemical name CAS-No. Classification Classification Concentration

EC-No. (67/548/EEC) (REGULATION [%]
Index-No. (EC) No
Registration 1272/2008)
number
distillates (petroleum), 64742-55-8 Asp. Tox. 1; H304 >= 20 - < 30
hydrotreated light 265-158-7
paraffinic 649-468-00-3
calcium 57855-77-3 Xi; R36 Skin Irrit. 2; H315 >= 1 - < 3
bis(dinonylnaphthalen 260-991-2 Xi; R38 Eye Irrit. 2; H319
esulphonate)
 For the full text of the R-phrases mentioned in this Section, see Section 16.
For the full text of the H-Statements mentioned in this Section, see Section 16.
Note L: The classification as a carcinogen need not apply if it can be shown that the
substance contains less than 3 % DMSO extract as measured by IP 346.

4. First-aid measures
Description of first aid measures
If inhaled:
Remove person to fresh air. If signs/symptoms continue, get medical attention.
Keep patient warm and at rest.
If unconscious place in recovery position and seek medical advice.
Keep respiratory tract clear.
If breathing is irregular or stopped, administer artificial respiration.
In case of skin contact:
Take off all contaminated clothing immediately.
Wash off immediately with soap and plenty of water.
Get medical attention immediately if irritation develops and persists.
Wash clothing before reuse.
Thoroughly clean shoes before reuse.
In case of eye contact:
If eye irritation persists, consult a specialist.
Rinse immediately with plenty of water, also under the eyelids, for at least 10 minutes.
If swallowed:
If unconscious place in recovery position and seek medical advice.
Keep respiratory tract clear.
Never give anything by mouth to an unconscious person.
Get medical attention if symptoms occur.
Move the victim to fresh air.
Most important symptoms and effects, both acute and delayed
Symptoms: No information available.
Risks: None known.
Indication of any immediate medical attention and special treatment needed
Treatment: No information available.

5. Fire-fighting measures
Extinguishing media
Suitable extinguishing media:
Use extinguishing measures that are appropriate to local circumstances and the surrounding
environment.
Unsuitable extinguishing media: High volume water jet
 Special hazards arising from the substance or mixture
Specific hazards during firefighting: Fire may cause evolution of:
Carbon oxides
Metal oxides
Nitrogen oxides (NOx)
Sulphur oxides
Advice for firefighters
Special protective equipment for firefighters:
In the event of fire, wear self-contained breathing apparatus.
Use personal protective equipment.
In the case of respirable dust and/or fumes, use self-contained breathing apparatus.
Exposure to decomposition products may be a hazard to health.
Further information:
Standard procedure for chemical fires.

6. Accidental release measures

Personal precautions, protective equipment and emergency procedures
Personal precautions:
Evacuate personnel to safe areas.
Use the indicated respiratory protection if the occupational exposure limit is exceeded
and/or in case of product release (dust).
Avoid breathing dust.
Refer to protective measures listed in sections 7 and 8.
Environmental precautions
Environmental precautions:
Try to prevent the material from entering drains or water courses.
Local authorities should be advised if significant spillages cannot be contained.
Methods and materials for containment and cleaning up
Methods for cleaning up:
Clean up promptly by sweeping or vacuum.
Keep in suitable, closed containers for disposal.
Reference to other sections
For personal protection see section 8.

7. Handling and storage

Precautions for safe handling
Advice on safe handling:
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the application area.
Wash hands and face before breaks and immediately after handling the product.
 Do not get in eyes or mouth or on skin.
Do not get on skin or clothing.
Do not ingest.
Do not repack.
These safety instructions also apply to empty packaging which may still contain product
residues.
Keep container closed when not in use.
Conditions for safe storage, including any incompatibilities
Requirements for storage areas and containers:
Store in original container.
Keep container closed when not in use.
Keep in a dry, cool and well-ventilated place.
To maintain product quality, do not store in heat or direct sunlight.
Containers which are opened must be carefully resealed and kept upright to prevent leakage.
Store in accordance with the particular national regulations.
Keep in properly labelled containers.
Specific end use(s)
Consult the technical guidelines for the use of this substance/mixture.

8. Exposure controls/personal protection

Control parameters
Contains no substances with occupational exposure limit values.
Exposure controls
Engineering measures
Maintain air concentrations below occupational exposure standards.
Personal protective equipment
Respiratory protection:
In the case of dust or aerosol formation use respirator with an approved filter.
Hand protection:
For prolonged or repeated contact use protective gloves.
The selected protective gloves have to satisfy the specifications of EU Directive 89/686/EEC
and the standard EN 374 derived from it.
The break through time depends amongst other things on the material, the thickness and
the type of glove and therefore has to be measured for each case.
Eye protection:
Tightly fitting safety goggles
Safety glasses with side-shields conforming to EN166
Hygiene measures:
Wash face, hands and any exposed skin thoroughly after handling.
Protective measures:
The type of protective equipment must be selected according to the concentration and
 amount of the dangerous substance at the specific workplace.
Choose body protection in relation to its type, to the concentration and amount of
dangerous substances, and to the specific work-place.
Environmental exposure controls
General advice:
Try to prevent the material from entering drains or water courses.
Local authorities should be advised if significant spillages cannot be contained.

9. Physical and chemical properties

I Information on basic physical and chemical properties
Form: paste
Colour: beige
Odour: characteristic
Odour Threshold: No data available
pH: No data available
Melting point/range: No data available
Boiling point/boiling range: No data available
Flash point: not applicable
Evaporation rate: No data available
Flammability (solid, gas): Combustible Solids
Lower explosion limit: No data available
Upper explosion limit: No data available
Vapour pressure: < 0.001 hPa, 20 °C
Relative vapour density: No data available
Density: 0.87 g/cm3, 20 °C
Water solubility: insoluble
Solubility in other solvents: No data available
Partition coefficient: noctanol/water: No data available
Auto-ignition temperature: No data available
Ignition temperature: No data available
Viscosity, dynamic: No data available
Viscosity, kinematic: No data available
Oxidizing properties: No data available
Other information
Sublimation point: No data available
Bulk density: No data available

10. Stability and reactivity

Reactivity
No hazards to be specially mentioned.
 Chemical stability
No decomposition if stored and applied as directed.
Possibility of hazardous reactions
Hazardous reactions: No dangerous reaction known under conditions of normal use.
Conditions to avoid
Conditions to avoid: No conditions to be specially mentioned.
Incompatible materials
Materials to avoid: No materials to be especially mentioned.
Hazardous decomposition products
Hazardous decomposition products: No decomposition if stored and applied as directed.

11. Toxicological information

Information on toxicological effects
Product
Acute oral toxicity: This information is not available.
Skin corrosion/irritation: This information is not available.
Serious eye damage/eye irritation: This information is not available.
Respiratory or skin sensitisation: This information is not available.
Germ cell mutagenicity
Genotoxicity in vitro: No data available
Genotoxicity in vivo: No data available
Carcinogenicity: No data available
Reproductive toxicity: No data available
Teratogenicity: No data available
Repeated dose toxicity: This information is not available.
Aspiration toxicity: This information is not available.
Further information: Information given is based on data on the components and the
toxicology of similar products.
Components:
distillates (petroleum), hydrotreated light paraffinic:
Acute oral toxicity: LD50: > 5,000 mg/kg, rat
Acute inhalation toxicity: LC50: > 5 mg/l, 4 h, rat, dust/mist
Acute dermal toxicity: LD50: > 5,000 mg/kg, rabbit \
Aspiration toxicity: May be fatal if swallowed and enters airways.
calcium bis(dinonylnaphthalenesulphonate):
Acute oral toxicityLD50: > 5,000 mg/kg, rat
Acute dermal toxicity: LD50: > 20,000 mg/kg, rabbit
Skin corrosion/irritation: rabbit, Result:
Irritating to skin., Classification: Irritating to skin.
Serious eye damage/eye irritation: rabbit, Result:
Irritating to eyes., Classification: Irritating to eyes.
12. Ecological information
Toxicity
Product
Toxicity to fish: No data available
Toxicity to daphnia and other aquatic invertebrates: No data available
Toxicity to algae: No data available
Toxicity to bacteria: No data available
Components:
distillates (petroleum), hydrotreated light paraffinic:
Toxicity to fish: LC50: > 100 mg/l, 96 h, Oncorhynchus mykiss (rainbow trout)
Toxicity to daphnia and other aquatic invertebrates: EC50: > 10,000 mg/l, 48 h, Daphnia
magna (Water flea)
Persistence and degradability
Product
Biodegradability: No data available
Physico-chemical removability: No data available
Bioaccumulative potential
Product
Bioaccumulative potential:
This mixture contains no substance considered to be persistent, bioaccumulating nor toxic
(PBT).
This mixture contains no substance considered to be very persistent nor very
bioaccumulating (vPvB).
Mobility in soil
Product
Mobility: No data available
Distribution among environmental compartments: No data available
Results of PBT and vPvB assessment
Product
Assessment:
This substance/mixture contains no components considered to be either persistent,
bioaccumulative and toxic (PBT), or very persistent and very bioaccumulative (vPvB) at levels
of 0.1% or higher.
Other adverse effects
Product
Additional ecological information: No information on ecology is available.

13. Disposal considerations

Waste treatment methods
Product:
 The product should not be allowed to enter drains, water courses or the soil.
Waste codes should be assigned by the user based on the application for which the product
was used.
Contaminated packaging:
Empty containers can be landfilled, when in accordance with the local regulations.

14. Transport information

UN number
ADR:
Not dangerous goods
IMDG:
Not dangerous goods
IATA:
Not dangerous goods
Proper shipping name
ADR:
Not dangerous goods
IMDG:
Not dangerous goods
IATA:
Not dangerous goods
Transport hazard class
ADR:
Not dangerous goods
IMDG:
Not dangerous goods
IATA :
Not dangerous goods
Packing group
ADR:
Not dangerous goods
IMDG:
Not dangerous goods
IATA:
Not dangerous goods
Environmental hazards
ADR:
Not dangerous goods
IMDG:
Not dangerous goods
IATA:
 Not dangerous goods
Special precautions for user:
No data available
Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code :
Not available

15. Regulatory information

Safety, health and environmental regulations/legislation specific for the substance or
mixture
REACH - Candidate List of Substances of Very High Concern for Authorisation (Article 59):
This product does not contain substances of very high concern (Regulation (EC) No
1907/2006 (REACH), Article 57).
Major Accident Hazard Legislation:
96/82/EC Update:
Petroleum products:
(a) gasolines and naphthas,
(b) kerosenes (including jet fuels),
(c) gas oils (including diesel fuels, home heating oils and gas oil blending streams) 13
Quantity 1: 2,500 t
Quantity 2: 25,000 t
Chemical Safety Assessment
This information is not available.

16. Other information

Full text of R-phrases referred to under sections 2 and 3
R36 Irritating to eyes.
R38 Irritating to skin.
Full text of H-Statements referred to under sections 2 and 3
H304 May be fatal if swallowed and enters airways.
H315 Causes skin irritation.
H319 Causes serious eye irritation.
Version: 1.3
Printed: 2019.09.26