HSE Orientation Training

Procedure
Document No. : OFS-HSE06-PRO-002-2020-R0
Document Level : 3
Document Title : HSE Orientation Training Procedure

Document Owner : HSE Offshore/Performance Assurance and Audit Department

Name Position Date Signature

Marthen
Prepared
Wangani Program and Training Specialist 31 August 2020
by:
a
Reviewed Teguh
Mgr HSE Performance Assurance and Audit 31 August 2020
by: Yuwono

Approved Asep
Sr Mgr HSE 31 August 2020
by: Bunawan
Document No.
OFS-HSE06-PRO-002-2020-R0 Procedure

Rev. 00 Page 3 of 11

HSE Orientation Training

Date: 31 August 2020

Additional Reviewers (as Applicable)

Name Position Date Signature

Document No.
OFS-HSE06-PRO-002-2020-R0 Procedure

Rev. 00 Page 4 of 11

HSE Orientation Training

Date: 31 August 2020

No part of this guideline may be reproduced, transmitted, and/or copied in any form or by any means,
including photocopying, without the written consent of Medco E&P.
Document No.
OFS-HSE06-PRO-002-2020-R0 Procedure

Rev. 00 Page 5 of 11

HSE Orientation Training

Date: 31 August 2020

Published by
Medco E&P Natuna
Jakarta, Indonesia

Revision Sheet

Document Number : OFS-HSE06-PRO-002-2020-R0

Document Level : 3
Document Title : HSE Orientation Training Procedure
Document Owner : HSE Performance Assurance and Audit - PA and Audit
Document No.
OFS-HSE06-PRO-002-2020-R0 Procedure

Rev. 00 Page 6 of 11

HSE Orientation Training

Date: 31 August 2020

REV. PART REVISION NOTES INITIATED BY DATE

00 31 August
 This document is produced for interim
purpose only and intended to serve as 2020
a guidance during the transitional term
prior to issuing the definitive
procedure.

 Should there is any inconsistency

between this document and other
applicable documents at Medco E&P
Natuna Ltd., the approver shall have
the discretion to determine the
prevailing term.

Changed document number from Sept 2021

MEPN/HSE/PRO/0014 to OFS-HSE06-
PRO-002-2020-R0
Doc No.
OFS-HSE06-PRO-002-2020-R0 PROCEDURE

Rev. 00 Page 7 of 11

HSE Orientation Training

Date: 31 August 2020

TABLE OF CONTENT
I. PURPOSE ………………………………………………………………………………..7
II. SCOPE ……………………………...…………………………………………………………7
III. DEFINITION AND ABREVIATION …………………………………………….………..7
IV. ROLES AND RESPONSIBILITY………………………………….……………………….
…..8
a. Manager Performance Assurance and Audit (PA & Audit).........................................
b. HSE Orientation Dedicated Trainer...........................................................................
c. Contract Owner/ Direct Supervisor/ Sponsor.............................................................
V. PROCEDURE ………………………………………………………………………………..9
VI. PROCEDURE AND HSE ORIENTATION CONTENTS MAINTENANCE ………...10

Appendices
APPENDIX A – REFERENCED DOCUMENTS ………………..………………………….11
Doc No.
OFS-HSE06-PRO-002-2020-R0 PROCEDURE

Rev. 00 Page 8 of 11

HSE Orientation Training

Date: 31 August 2020

I. PURPOSE
To establish and implement a process that provides employees, contractors and
visitors with the required information, knowledge, basic skills to perform any activities
at offshore facilities and/or office building in a safe, professional, and environmentally
manner.
.
II. SCOPE
This Procedure is applied to all employees, contractors and visitors in Medco E&P
Natuna Ltd, Medco Sampang Pty. Ltd., Ophir Madura Offshore Pty. Ltd. (herein later
called as “Company”)

III. DEFINITION AND ABREVIATION

Company: Medco E&P Natuna Ltd., Medco Sampang Pty. Ltd., and/or
Ophir Madura Offshore Pty. Ltd.

Contractors: Non-Company employees performing work for or on behalf

of Company.

Contract Owner: Company employee who is assigned to manage particular

contract and as a focal point to be contacted in regard of the
fulfillment of contract

Dedicated Trainer: A trainer who has been assessed and declared to be

passed to deliver HSE Orientation training materials.

Employees: Personnel who work for Company under a work agreement

and receive payment.

HSE Passport: A tool in form of digital or virtual card to record all relevant
data of personnel (employees, contractors, visitors) such as
personal data, emergency contacts, medical records, MCU
and HSE Orientation records, training and competency
records, mobilization/demobilization, etc.
Doc No.
OFS-HSE06-PRO-002-2020-R0 PROCEDURE

Rev. 00 Page 9 of 11

HSE Orientation Training

Date: 31 August 2020

On-Site Trainer: A dedicated trainer who delivers HSE Orientation training

materials at site.

Post-Test: A written test given to all participants/ trainees who have

completed their initial HSE Orientation training to measure
the understanding and effectiveness the system

PTS: Stands for Personal Transportation System – a flight

reservation system for personnel who are going offshore.

Refresher Test: A written test given to all personnel who have their HSE
Orientation training expired. The result will determine
whether the HSE Orientation refresher training is required.

Sponsor: Company employee who is assigned as a sponsor and act

as a focal point to make an arrangement of the offshore
visits for visitor(s).

IV. ROLES AND RESPONSIBILITY

a. Manager Performance Assurance and Audit (PA & Audit)

Manager PA & Audit in coordination with relevant parties will be responsible to:
a. Assign person(s) as dedicated HSE Orientation Trainer
b. Review and approve the contents of HSE Orientation materials
c. Review and approve the post-test materials
d. Conduct annual review of the effectiveness of HSE Orientation training
implementation

b. HSE Orientation Dedicated Trainer

HSE Orientation Dedicated Trainer shall be responsible to:
a. Develop, review and revise the HSE Orientation materials.

b. Notify & send the revised HSE Orientation materials to the Manager PA &
Audit to obtain approval
Doc No.
OFS-HSE06-PRO-002-2020-R0 PROCEDURE

Rev. 00 Page 10 of 11

HSE Orientation Training

Date: 31 August 2020

c. Develop Post-Test materials to determine whether participant/trainee is

pass or not

d. In coordination with HSE admin to input the updated HSE Orientation

training record into the electronic database system

e. Prepare a monthly report of the implementation of HSE Orientation training.

The report (at a minimum) consists of; number of personnel have been
trained, number of personnel passed/not passed the training, any material
required changes (if any), etc.

c. Contract Owner/ Direct Supervisor/ Sponsor

Contract Owner/ Direct Supervisor/ Sponsor shall be accountable/responsible
to:
a. Ensure the HSE Orientation training of his/her personnel are VALID

b. Register his/her personnel to the scheduled HSE Orientation training

session as required

c. Keep the training record of the HSE Orientation training

V. PROCEDURE
1. All employees, contractors, and visitors who are going to visit offshore fields
(incl. Matak Base), have to get their valid HSE Orientation
2. New employees, contractors and/or visitors who have not received the HSE
Orientation shall undergo the session prior to visiting offshore fields
3. Direct Supervisor/ Contract owner/ Sponsor shall inform and register their
respective employees, contractors, or visitors to the HSE Orientation
Dedicated Trainer
4. A regular (weekly) HSE Orientation training session is scheduled and held
in Jakarta. If the regular class (offline) is unable to be conducted, a virtual/
online class session or other applicable method have to be held as an
alternative
5. HSE Orientation training contents should include at a minimum the
following:
a. Company Policy
b. HSE Management System in brief
c. Life Saving Rules
d. Hazard Identification/ Risk Management (Top 5 major hazards)
e. Electrical Safety (Electronic devices)
Doc No.
OFS-HSE06-PRO-002-2020-R0 PROCEDURE

Rev. 00 Page 11 of 11

HSE Orientation Training

Date: 31 August 2020

f. Relevant critical HSE standards/ procedures/ programs (such as:

Work Permit, Electrical Safety, Process Safety, Stop Work
Temporarily, Safety Card, etc.)
g. Introduction to office building and offshore facilities (includes
applicable site-specific procedures)
h. Emergency Preparedness (e.g. muster points, etc.)
i. Waste Management
j. Ethics and Code of Conduct
k. Sustainability Development
6. All participants/ trainees have to undergo the Post-Test examination to
ensure the understanding of the HSE Orientation materials
7. The result of post-test would reflect the effectiveness of HSE Orientation
training delivery
8. Participants/ trainees who have not passed the post-test, will be given the
second examination within one week since the first test conducted
9. In the event where result of the second examination is not pass, the
participants/ trainees should undergo the full HSE Orientation training in the
next opportunity
10. All data of participants/ trainees (consist of; name of participants/trainees,
PTS ID, date of training, and expiry date of training) who have passed the
post-test will be recorded and inputted into the electronic database system
(e.g. PTS, HSE Passport)
11. The HSE Orientation training is valid for 4 (four) years
12. Personnel who have their HSE Orientation training expired, shall undergo a
refresher test to determine whether or not the refresher training is required
13. Personnel who have not passed the test, shall undergo the refresher HSE
Orientation training

VI. PROCEDURE AND HSE ORIENTATION CONTENTS MAINTENANCE

1. This procedure document will be regularly reviewed as per HSE Document
Procedure
2. The HSE Orientation training materials (includes the Post-Test and the
Refresher Test) shall be reviewed annually along with the reviews of its
effectiveness
3. Any modification on the HSE Orientation training materials shall obtain
approval from Manager Performance Assurance and Audit
Doc No.
OFS-HSE06-PRO-002-2020-R0 PROCEDURE

Rev. 00 Page 12 of 11

HSE Orientation Training

Date: 31 August 2020
Doc No.
OFS-HSE06-PRO-002-2020-R0 PROCEDURE

Rev. 00 Page 13 of 11

HSE Orientation Training

Date: 31 August 2020

Appendix A – Referenced Documents

Reference No. Document No. Document Title

Undang-undang Tentang Kesehatan dan
1 Undang-undang No. 1 Tahun 1970
Keselamatan Kerja
2 MEPN/HSE/GEN/0009 MEPN HSE Management System 2017, Element 9
3 MEPNHSEGEN0002-Rev0 BU HSE Training Procedure
4 MEPN-PRO-HSE-0011 HSE Passport Procedure