KENR8654-03

June 2022 Harness And Wire Electrical Schematic Symbols

Symbols

45 Pressure Temperature Level Flow Circuit Breaker

Symbol
Component Location - Volume 1 Symbol Symbol Symbol Symbol
Schematic Machine Schematic Machine
Component
Location Location
Component
Location Location Symbols and Definitions
56 51 25
Alarm - Backup B-8 16 Relay - Main Power A (B) D-9 44
Fuse: A component in an electrical circuit that will open the circuit if too much current flows
54 Alternator (A)
Alternator (B)
B-5
E-6
14
33
Relay - Main Power B (A)
Relay - Main Power B (B)
C-7
D-9
45
44 through it.
13 48 Battery (A) A-5 11 Relay - Main Power C (A) C-7 45

50 20 Battery (B)
Breaker - Main (A)
D-7
B-6
13
45
Relay - Main Power C (B)
Relay - Main Power D (A)
D-9
C-7
44
45
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.
21 Breaker - Main (B) E-7 45 Relay - Main Power D (B) D-9 44

18 46 Breaker - Roading (A) A-5 45 Relay - Start (A) B-5 45 Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
40 Breaker - Roading (B)
Coil - Ferrite Asy.
D-7
B-2
44
19
Relay - Start (B)
Resistor - DMML Alternator (A)
E-6
B-5
45
14
No circle indicates that the wire cannot be disconnected from the component.

Control - Auxiliary Hydraulic Control D-1 47 Sender - Fuel Level (A) D-7 12
Ground (Wired): This indicates that the component is connected to a grounded wire. The
33 Control - Operator Interlock
Diode - Block (A)
E-1
A-5
48
15
Sender - Fuel Level (B)
Socket - Power +12 Volts
E-9
D-3
46
6
grounded wire is fastened to the machine.

Fuses - Block 1 D-3 6 Solenoid - (C-) High Flow (A) C-3 8

Ground (Case): This indicates that the component does not have a wire connected to ground.
Fuses - Block 2 (Work Tools) D-5 6 Solenoid - (C+) High Flow (A) C-3 8
It is grounded by being fastened to the machine.
Glow Plugs (A) A-5 15 Solenoid - A1 C-4 8
Glow Plugs (B) D-6 15 Solenoid - A2 C-4 8

216B2, 226B2, 232B2, 236B2 , 242B2,

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
Ground - Engine Stud (A) B-5 49 Solenoid - Boost Flow (A) C-3 8
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
15 Ground - Engine Stud (B)
Ground - Lower Frame
E-6
E-9
49
21
Solenoid - Cold Start Pump (B)
Solenoid - Continuous Flow
D-6
C-3
14
8
16
and 252B2 Skid Steer Loader
Ground - Lower Platform (Not Shown) C-2 39 Solenoid - Fuel Shutdown (A) B-5 33
Sender: A component that is used with a temperature or pressure gauge. The sender
Ground - Upper Frame E-9 21 Solenoid - Fuel Shutdown (B) E-6 14
measures the temperature or pressure. Its resistance changes to give an indication to
T
the gauge of the temperature or pressure.

247B2 and 257B2 Multi-Terrain Loader

Ground - Upper Frame Stud (A) B-7 51 Solenoid - Impl Pilot (248,268,High Flow) A-3 19
Ground - Upper Frame Stud (B) D-9 11 Solenoid - Implement Pilot B-2 19
Handle - 1 SW - LH E-1 20 Solenoid - Parking Brake (Not Shown) C-2 39 Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.

Electrical System
Handle - 2 SW - LH 20 Solenoid - Quick Coupler (A) B-7 11 It has a coil that makes an electromagnet when current flows through it. The
14 Handle - 2 SW - RH
E-2
C-2 19 Solenoid - Quick Coupler (B) C-9 53 electromagnet can open or close the switch part of the relay.
Handle - 2 SW - RH C-1 19 Solenoid - Transmission E-2 20
Handle - 3 SW / Roller - RH C-1 19 Solenoid - Two Speed (B) (Not Shown) C-3 39 Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
Handle - 5 SW - LH E-2 20 Solenoid - Valve Grp DVTR ARC MTL (B) MJH12175-UP coil that makes an electromagnet when current flows through it. The electromagnet
D-9 52
Horn - Forward (A) C-7 51 248 High Flow can open or close a valve or move a piece of metal that can do work.
SCH2825-UP
10 Horn - Forward (B) E-9 52 Solenoid - Valve Grp DVTR XR XRMTL (A) A-7 52
SLK8300-UP
Lamp - License B-9 16 Solenoid - Valve Grp DVTR XR XRMTL (B)
D-9 52
Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
Lamp - Signal Group B-9 16 268 High Flow MTL5700-UP activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
Lamp - Stop/Tail - LH Attachment B-8 18 Stud - Power (A) B-5 45 RLL7700-UP that make electromagnet when current flows through them. It also has an internal switch that places
Lamp - Stop/Tail - RH Attachment B-8 17 Stud - Power (B) E-7 44 BXM4775-UP the latch coil circuit open at the time the coil latches.
17 Motor - Fuel Prime Pump (B)
Motor - Starter (A)
C-9
A-6
11
10
Switch - Air Filter Indicator (A)
Switch - Air Filter Indicator (B)
B-7
C-9
45
44
HEN8070-UP
Harness and Wire Symbols
SCP5410-UP
6 Motor - Starter (B)
Motor - Water Pump
D-7
E-5
50
25
Switch - Backup Pressure
Switch - Cold Start Thermo Temp (B)
E-2
D-6
20
14 Wire, Cable, or Harness Harness Identification Letter(s):
Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
52 7
Relay - (C-) Fuse Block 2 D-5 6 Switch - Engine Coolant Temperature (A) A-5 14
Harness Identification Letters and
11 44 53 47 Relay - (C+) Fuse Block 2
Relay - (C+/C-) Fuse Block 2
E-5
E-5
6
6
Switch - Engine Coolant Temperature (B)
Switch - Engine Oil Pressure (A)
E-6
A-5
33
33
Harness Connector Serialization
Codes (see sample).
Harness Connector Serialization Code:
The "C" stands for "Connector" and the
12 55 Relay - (C1) Fuse Block 2 D-5 6 Switch - Engine Oil Pressure (B) D-6 14
AG-C4 L-C12
number indicates which connector in the
harness (C1, C2, C3, ...).

8 19 Relay - (C2) Fuse Block 2

Relay - High Flow (A)
D-5
C-4
6
6
Switch - High Flow (248,268)
Switch - Hydraulic Filter Bypass (A)
A-3
C-7
19
13
111-7898 3E-5179
L-C12
3E-5179
49 Relay - Cold Start (A)
Relay - Cold Start (B)
B-3
E-6
45
45
Switch - Hydraulic Filter Bypass (B)
Switch - Hydraulic Oil Temp (A)
D-9
D-7
54
51
Part Number: for Connector Plug 1
Part Number: for Connector Receptacle
Relay - Fuel Pump C-9 11 Switch - Hydraulic Oil Temp (B) E-9 51 2
Relay - Lockout (248,268,Boost Flow) A-4 7
5A
Relay - Main Power A (A) C-7 44 Plug Receptacle Component
Pin or Socket Number Fuse (5 Amps) 9X-1123 Part Number

20 (A) = 216B / 226 / 232 / 242 / 247 / 257

(B) = 236B / 246 / 248 / 252 / 262 / 267 / 268 / 277 / 287 1 Deutsch connector: Typical representation
325-AG135 PK-14
25 2
of a Deutsch connector. The plug contains all
sockets and the receptacle contains all pins.
Harness identification code:
Volume 1 of 2: Engine and Platform This example indicates wire group 325,
wire 135 in harness "AG".
Wire Gauge*
Wire Color
1 Sure-Seal connector: Typical representation
45 21 51 52 19 PUBLICATIONS.CAT.COM 2
of a Sure-Seal connector. The plug and receptacle
contain both pins and sockets.
*Wire gauge is shown in AWG (American Wire Gauge)
but could also be shown in metric denoted with mm
54
44 © 2022 Caterpillar. All Rights Reserved. CAT, CATERPILLAR, LET’S DO THE WORK, their respective logos, “Caterpillar Corporate Yellow”, the

17 “Power Edge” and Cat “Modern Hex” trade dress as well as corporate and product identity used herein, are trademarks of Caterpillar and may not
be used without permission.
56
18 8
16
40
7

33 46 Connector Location - Volume 1

Schematic Machine
Connector Number
Location Location
47 CONN 1 C-9, B-7 56
CONN 2 B-8, B-9 18
CONN 3 B-8, B-9 13
14

KENR8654-03 VOL 1 of 2
CONN 4 B-7, B-9 52
CONN 5 B-9, A-7 46
CONN 6 E-9 55
CONN 8 A-6, C-8 34

(Dimensions: 39 inches x 24 inches)

CONN 9 B-6, C-8 34
15 CONN 10 C-8 34
CONN 11 C-8, B-6 51
CONN 12 C-6, D-8 51
CONN 13 C-6 , D-8 51

13 11 10 6 48
CONN 14 C-6, D-8 51

53 49 12 50 55 CONN 15
CONN 16
E-8, C-6
E-8, D-6
51
12
CONN 17 C-7 44
CONN 19 E-7 45
CONN 20 D-6 51
CONN 21 B-6 51
CONN 22 D-6 13
CONN 23 E-5 14

MACHINE HARNESS CONNECTOR AND COMPONENT LOCATIONS CONN 25

CONN 26 TOOL
E-5
E-4
7
40
CONN 27 A-4, B-2 7
CONN 28 B-4, C-4 7
CONN 29 C-4 39
CONN 30 C-4 6

20 Page,
CONN 31 SERVICE D-3 19
CONN 32 A-3 19
CONN 33 A-3, B-2 19
The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.
 (20) LH HANDLE
223-3726 (ITT) (20) HANDLE LH REXROTH 1PB
P-C7 E-C1 E-C7 223-3725 (ITT - HORN AND CONT FLOW ONLY)
1552252 3E5179 110-E2 GN- 18 9X1054 SYMBOL ORIENTED ACCORDING TO OPERATOR USAGE; 218-6117
30 SYMBOL ORIENTED ACCORDING TO OPERATOR USAGE;
(21) UPPER FRAME 110-P58 GN- 16 1 110-E1 GN- 16 110-E14 GN- 18 109-E19 RD- 12 1
86 114-A79 RD- 18 MACHINE FORWARD CORRESPONDS TO RIGHT SIDE
OF DIAGRAM SHEET MACHINE FORWARD CORRESPONDS TO RIGHT SIDE
GROUND 200-P89 BK- 18 2 200-E4 BK- 18 L987-E17 WH- 18 5 120-A54 YL- 18
(45) COLD START RELAY (B) OF DIAGRAM SHEET
200-P13 BK- 18 3 200-E12 BK- 18 110-E1 GN- 16 200-E12 BK- 18 2
85 200-W5 BK- 14 CONN TO Y-C1 120-A117 YL- 18
NOTE B 102-P2 RD- 14 308-P93 YL- 18 4 308-E8 YL- 18 877-E10 YL- 12 4 115-1615 WORK TOOL (ATCH) HARN 120-A116 YL- 18
87 A-C3 CONT FLOW HORN
UPPER LOWER FRAME GND STRAP 102-P2 RD- 14 C444-P66 YL- 18 5 C444-E9 YL- 18 200-E4 BK- 18 3 225-8014 OR 225-8015
87a 1552252
8M-4963 109-P38 RD- 8 109-P20 RD- 12 A346-P42 BU- 18 6 A346-E16 BU- 18 200-E12 BK- 18 200-W7 BK- 14 120-A12 YL- 18
NOTE D 1 PLUGGED
109-P53 RD- 8 109-P24 RD- 12 403-P50 GN- 18 7 403-E7 GN- 18 200-W1 BK- 14 N-C2 122-A78 RD- 16 120-A116 YL- 18 1 PLUGGED
E-C6 WT-C5 W-C2 W-C1 N-C1 2 PLUGGED
109-P56 RD- 12 109-P53 RD- 8 405-P34 GY- 18 8 405-E5 GY- 18 308-E8 YL- 18 200-W6 BK- 14 NOTE T 1561460 128-A49 PK- 18 322-A53 GY- 18 2 BR-20
P-C19 9X1054 1552264 3E3388 1552264 3E3388 3 PLUGGED
110-P58 GN- 16 406-P33 PU- 18 9 406-E3 PU- 18 403-E7 GN- 18 200-A110 BK- 14 112-A71 PU- 12 114-A79 RD- 18 114-A79 RD- 18 3 YL-20
1779646 30 4 PLUGGED
200-P13 BK- 18 109-P23 RD- 12 TO WKTL ATCH L987-P62 WH- 18 10 L987-E17 WH- 18 405-E5 GY- 18 109-E18 RD- 12 1
86 (45) START RELAY (B) 200-WT18 BK- 14 1 200-W7 BK- 14 A571-W12 PU- 14 200-W1 BK- 14 1 200-N11 BK- 14 200-N11 BK- 14 A 306-A11 GN- 18 112-A73 PU- 12 120-A54 YL- 18 203-A20 BK- 18 4 PLUGGED
5 PLUGGED
200-P89 BK- 18 109-P25 RD- 12 111-P16 YL- 12 1 HARNESS WT-C6 M732-P1 OR- 18 11 M732-E13 OR- 18 406-E3 PU- 18 A346-E16 BU- 18 5 115-1615 A752-WT16 BR- 14 2 A752-W8 BR- 14 A752-W2 BR- 14 2 A752-N2 BR- 14 A571-N8 PU- 14 B 307-A67 OR- 18 122-A97 RD- 16 120-A116 YL- 18 5 DK GN-20
2 SPEED 6 PLUGGED
203-P127 BK- 18 109-P38 RD- 8 200-P120 BK- 12 2 (LOC E-6) 12 877-E10 YL- 12 M732-E13 OR- 18 2
85 M906-WT13 BU- 14 3 M906-W3 BU- 14 A752-W8 BR- 14 M906-W3 BU- 14 3 M906-N3 BU- 14 M906-N3 BU- 14 C 321-A55 BR- 18 122-A82 RD- 16 781-A98 PK- 18 6 DK BU-20
TRIGGER 7 PLUGGED
(21) LOWER FRAME 308-P93 YL- 18 304-E11 WH- 12 4 M907-WT10 GY- 14 4 M907-W4 GY- 14 M907-W4 GY- 14 4 M907-N4 GY- 14 M907-N4 GY- 14 D 322-A53 GY- 18 122-A78 RD- 16 203-A102 BK- 18 203-A102 BK- 18 7 LT GN-20
87
GROUND 403-P50 GN- 18 109-P56 RD- 12 CONN 16 CONN 19 A346-E16 BU- 18 3
87a
200-WT19 BK- 14 5 200-W5 BK- 14 A752-W9 BR- 14 200-W5 BK- 14 5 200-N5 BK- 14 200-N5 BK- 14 E 674-A15 BU- 18
F21 GAUGE
113-8490 126-A84 PK- 18 203-A90 BK- 18 782-A99 GY- 18 8 LT BU-20
8
9
PLUGGED
PLUGGED
CONT FLOW
405-P34 GY- 18 C444-E9 YL- 18 M733-WT4 PK- 14 6 M733-W11 PK- 14 A752-W2 BR- 14 M733-W11 PK- 14 6 M733-N6 PK- 14 M733-N6 PK- 14 F 122-A78 RD- 16 676-A3 PU- 18 10A 128-A104 PK- 14 321-A55 BR- 18 9 PLUGGED
10 PLUGGED
NOTE B 406-P33 PU- 18 110-P58 GN- 16 110-P98 GN- 14 203-P127 BK- 18 L987-E17 WH- 18 C460-WT14 BU- 14 7 C460-W10 BU- 14 C460-W10 BU- 14 7 C460-N7 BU- 14 C460-N7 BU- 14 G 128-A49 PK- 18 944-A59 OR- 18 128-A49 PK- 18 322-A53 GY- 18 P982-A27 BU- 18 10 GY-20
A346-P42 BU- 18 110-P86 GN- 18 M732-E13 OR- 18 A571-WT15 PU- 14 8 A571-W12 PU- 14 C460-W10 BU- 14 A571-W12 PU- 14 8 A571-N8 PU- 14 A752-N2 BR- 14 H F13 PWR PORT 11 YL-18
200-A110 BK- 14 945-A58 BR- 18 781-A98 PK- 18 P993-A19 OR- 18 11 OR-20
113-8490
1

12 GN-18
C444-P66 YL- 18 110-P102 GN- 18 ASSEMBLE 10A 200-A86 BK- 18 782-A99 GY- 18 203-A90 BK- 18 12 YL/BU-20
L987-P62 WH- 18
M732-P1 OR- 18 111-P16 YL- 12
P-C14
1673693
STRAP CAB GND 109-E20 RD- 4 CONN 23 M733-W11 PK- 14
M906-W3 BU- 14
CONN 25 CONN 26 306-A11 GN- 18 C460-A56 BU- 14
A-C14 F19 INTLK CONT
200-A96 BK- 18 975-A46 WH- 18
FROM BOSS ON STRAP CAB GND 307-A67 OR- 18 E918-A45 GN- 18 200-A110 BK- 14 H416-A6 GN- 18 WKTL "C2" WKTL "C1"
112-P10 PU- 12 105-P32 RD- 16 1 CAB GND M907-W4 GY- 14 1733139 113-8490 (48) OPERATOR INTERLOCK CONTROL
UPPER FRAME AS. 7G-1060 321-A55 BR- 18 F780-A42 PK- 18 10A P982-A27 BU- 18
112-P12 PU- 12 110-P98 GN- 14 2 TO CAB GND W-C3 322-A53 GY- 18 G982-A38 PK- 18 123-A83 WH- 18 A 306-A11 GN- 18 P993-A19 OR- 18 A-C4 154-4233
E-C2 (33) ALTERNATOR(B) 1552269 (20) HANDLE LH REXROTH 2PB
112-P15 PU- 12 117-P105 YL- 18 3 NOTE B G984-A43 PK- 18 145-A1 BU- 18 B 307-A67 OR- 18 1506764
P-C18 1073134 239-0772 (25) MOTOR - WATER PUMP GP F18 F SHUTOFF 218-6118 (HORN AND CONT FLOW ONLY
118-P57 GY- 14 4 200-W6 BK- 14 1 126-A84 PK- 18 C 85 86 A-C17 321-A55 BR- 18 126-A84 PK- 18 1 + BATTERY
1552267 "90 A" 233-5719 113-8491 1733137 SYMBOL ORIENTED ACCORDING TO OPERATOR USAGE;
122-P51 RD- 18 119-P3 PK- 18 5 C444-E9 YL- 18 1 P A752-W9 BR- 14 2 674-A15 BU- 18 G985-A44 PU- 18 549-A114 PK- 18 D 10A 322-A53 GY- 18
"5.6 A @ 40 psi" 87 30 MACHINE FORWARD CORRESPONDS TO RIGHT SIDE
(51) HYDRAULIC OIL A 122-P91 RD- 16 122-P91 RD- 16 6 308-E8 YL- 18 2 I B+
1

109-E20 RD- 4 676-A3 PU- 18 H791-A100 GN- 18 110-A39 GN- 14 E A 112-A73 PU- 12 122-A78 RD- 16 201-A2 BK- 16 3 - BATTERY
OF DIAGRAM SHEET
TEMPERATURE SWITCH(B) WH-16 B 404-P22 YL- 18 122-P128 RD- 16 123-P92 WH- 18 7 403-E7 GN- 18 3 L 944-A59 OR- 18 H792-A101 BR- 18 A571-A115 PU- 14 F RLY 1 C 112-A71 PU- 12 549-A114 PK- 18 122-A82 RD- 16
87A
236-1872 BK-16 C 200-P84 BK- 18 127-P31 OR- 18 8 945-A58 BR- 18 M901-A23YL- 18 144-A89 GN- 16 G 146-9439 BLACK 674-A15 BU- 18 122-A97 RD- 16 HORN 5
128-P5 PK- 18 9 F20 BEAC0N
T C460-A56 BU- 14 H 676-A3 PU- 18 126-A84 PK- 18
200-P13 BK- 18 134-P26 YL- 16 200-WT1 BK- 12
113-8490
10 E918-A45 GN- 18 P981-A60 PU- 18 BLACK 10A 128-A49 PK- 18 1 PLUGGED
7
200-P89 BK- 18 135-P21 BU- 16 11 111-WT2 YL- 12 F780-A42 PK- 18 P983-A28 GN- 18 781-A98 PK- 18 128-A104 PK- 14
P-C13 200-P111 BK- 18 144-P18 GN- 16 12 TO LOWER PLATF F2 RLY 1 2 RD-18
(46) FUEL LEVEL SENDER (B) (44) POWER STUD(B) G982-A38 PK- 18 P987-A24 GN- 18 782-A99 GY- 18 200-A70 BK- 18 9
1552269 200-P110 BK- 18 306-P59 GN- 18 HARNESS A-C11 ENG GND STRAP 113-8490 3 BK-18
224-8544 - BETA SSL 13
114-4516 G984-A43 PK- 18 P991-A63 PK- 18 10A 944-A50 OR- 18 200-A86 BK- 18 4 PLUGGED
231-2105 - ALPHA SSL PK-18 1 447-P14 PK- 18 200-P88 BK- 18 307-P4 OR- 18 14 (LOC D-6) 7G-1060 G985-A44 PU- 18 944-A59 OR- 18 200-A96 BK- 18 676-A3 PU- 18 11 ARMREST/SEAT STATUS LAMP
5 PLUGGED
231-2106 - 247/257 BK-18 2 200-P83 BK- 18 200-P106 BK- 14 308-P95 YL- 18 15 DIODE 1 H791-A100 GN- 18 945-A52 BR- 18 306-A11 GN- 18
200-P108 BK- 18 321-P7 BR- 18 215-5564 F5 LH TAIL 6 PLUGGED
16 H792-A101 BR- 18 945-A58 BR- 18 307-A67 OR- 18 A958-A4 WH- 18 13 PARKING BRAKE SOL
200-P109 BK- 18
113-8490 7 PLUGGED
322-P19 GY- 18 17 109-P38 RD- 8 109-P79 RD- 4 M901-A23YL- 18 105-A76 RD- 16 10A 674-A15 BU- 18 8 PLUGGED
200-P114 BK- 18 614-P75 PU- 14 18 109-P53 RD- 8 ASSEMBLE ENG GND STRAP 200-WT18 BK- 14 P981-A60 PU- 18 109-A74 RD- 12 C460-A56 BU- 14 676-A3 PU- 18
617-P70 BR- 18 19 109-P56 RD- 12 FROM ENGINE FLYWHEEL HSG 200-WT19 BK- 14 85 86 F6 RH TAIL 9 PLUGGED
(49) ENGINE GROUND 111-WT2 YL- 12 P983-A28 GN- 18 110-A39 GN- 14 E918-A45 GN- 18 944-A50 OR- 18
TO ENGINE GND STUD ON FUSE C+ 113-8490 10 PLUGGED
200-P83 BK- 18 618-P71 YL- 18 20
STUD (B) A571-WT15 PU- 14 P987-A24 GN- 18 112-A71 PU- 12 10A F780-A42 PK- 18 944-A59 OR- 18
BACK SIDE OF FUEL TANK
87 30 113-8490 A-C15 11 BU-18
200-P80 BK- 16 674-P29 BU- 18 21 109-WA1 RD- 12 A752-WT16 BR- 14 200-WT1 BK- 12 10A P991-A63 PK- 18 112-A72 PU- 12 G982-A38 PK- 18 945-A52 BR- 18 18
HE-C2 HE-C1 P-C12 200-P82 BK- 18 676-P30 PU- 18 22 (INCLUDED IN LOWER FRAME AS.) NOTE B C460-WT14 BU- 14 WT-C1 1791311 F9 COLD ST 12 GY-18
(6) RELAY C+ 112-A73 PU- 12 G984-A43 PK- 18 945-A58 BR- 18 19
1552269 3E3364 1552269 1733139 87A 113-8490 CONT FLOW
200-P84 BK- 18 F780-P35 PK- 18 23
146-9439 114-A79 RD- 18 617-A93 BR- 18 A 10A G985-A44 PU- 18 E918-A45 GN- 18
(52) FORWARD HORN (B) 1 322-HE1 GY- 18 1 322-P19 GY- 18 200-P103 BK- 16 M901-P36 YL- 18 24 109-E18 RD- 12 M733-WT4 PK- 14 200-WT18 BK- 14 H791-WT3 GN- 18 A 117-A77 YL- 18 618-A94 YL- 18 B H758-A66 BR- 18 F780-A42 PK- 18
2 200-HE2 BK- 18 2 200-P82 BK- 18 E918-P37 GN- 18 25 109-E19 RD- 12 M906-WT13 BU- 14 200-WT19 BK- 14 B
F10 RADIO
164-9425 114-A79 RD- 18 118-A80 GY- 14 127-A85 OR- 18 C H759-A62 OR- 18 G982-A38 PK- 18
E-C3 WT-C3 113-8490 A-C10
200-P120 BK- 12 944-P81 OR- 18 26 M907-WT10 GY- 14 200-WT17 BK- 12 M733-WT4 PK- 14 C 120-A54 YL- 18 119-A68 PK- 18 119-A68 PK- 18 D 10A G984-A43 PK- 18
CONN 6 203-P78 BK- 18
945-P77 BR- 18
P981-P41 PU- 18
27
28
101-E6 RD- 4 1

105A
1

1
109-E21 RD- 8
109-E20 RD- 4 110-E2 GN- 18
2364701
1 (14) FUEL SHUTDOWN SOLENOID (B)
781-WT12
782-WT11
PK- 18
GY- 18
H792-WT5
H759-WT6
BR- 18
OR- 18
D
E
85 86
A
1733138
111-WT2 YL- 12
122-A82 RD- 16
122-A97 RD- 16 120-A54 YL- 18
120-A54 YL- 18
134-A87 YL- 16
E
F
F8 BKUP ALARM
H791-A100 GN- 18
H792-A101 BR- 18
G985-A44 PU- 18
H758-A66 BR- 18 120-A12 YL- 18
1552269
1 BK-18 (20) BACKUP PRESSURE SWITCH
P988-A5 OR- 18 24 IMPL PILOT SOL

(45) MAIN BREAKER (B)

87 30 (6) RLY (C+/C-) 113-8490
203-P127 BK- 18 203-P116 BK- 18 G982-P40 PK- 18 29 249-7346 P984-WT7 YL- 18 F C 200-WT1 BK- 12 126-A84 PK- 18 122-A82 RD- 16 135-A88 BU- 16 G 10A M901-A23YL- 18 H759-A62 OR- 18 321-A55 BR- 18 2 BK-18 192-0836 26
P983-P60 GN- 18 30 171-2212 NOTE B A571-WT15 PU- 14 A751-WT8 YL- 16 G HF PRESS SW GRAY 128-A104 PK- 14 122-A97 RD- 16 614-A92 PU- 14 H P981-A60 PU- 18 L998-A30 OR- 18
87A 146-9439 F3 FR WORK LT A-C12
307-P52 OR- 18 307-P4 OR- 18 G984-P45 PK- 18 31 A751-WT8 YL- 16 H758-WT9 BR- 18 H
F3 WKTL 200-A86 BK- 18 123-A83 WH- 18 GREEN P983-A28 GN- 18
E-C4 113-8491 1552269
BLACK
307-P9 OR- 18
CONN 15 1003320 (33) ENGINE COOLANT
A752-WT16 BR- 14
15A
113-8491 200-A96 BK- 18
549-A114 PK- 18
124-A107 RD- 14
125-A108 RD- 14
15A
F4 RR WORK LT
P984-A113 YL- 18
P987-A24 GN- 18
L999-A26 GN- 18
L999-A65 GN- 18 H416-A6 GN- 18 1 (20) TRANSMISSION SOLENOID
H416-A6 GN- 18 29 XMSN SOL

308-P117 YL- 18 P-C1 406-E3 PU- 18 1 TEMPERATURE SWITCH(B) C460-WT14 BU- 14 781-A98 PK- 18 126-A84 PK- 18 P991-A63 PK- 18 M901-A23YL- 18 975-A46 WH- 18 2 195-9700 31
1552273 113-8491
308-P93 YL- 18 308-P94 YL- 18 200-E4 BK- 18 2 217-5793 DIODE 2 782-A99 GY- 18 127-A85 OR- 18 15A P978-A29 GN- 18 "0.78A MIN 1.11A CONTINUOUS"
308-P95 YL- 18 1
T
H758-WT9 BR- 18 215-5564 944-A50 OR- 18 128-A104 PK- 14 P979-A35 YL- 18
A751-P8 YL- 16 2 TO LOWER PLATFORM PA-C19 WT-C6 H759-WT6 OR- 18 945-A52 BR- 18 P980-A25 OR- 18 122-A97 RD- 16
321-P7 BR- 18 A752-P129 BR- 14 3 HARNESS A-C1 109-WA1 RD- 12 1779646 1779641 H791-WT3 GN- 18 H758-A66 BR- 18 134-A87 YL- 16 120-A117 YL- 18 P981-A60 PU- 18 122-A78 RD- 16
322-P19 GY- 18 G985-P49 PU- 18 4 (LOC C-6) 111-PA16 YL- 12 1 111-WT2 YL- 12 H792-WT5 BR- 18 85 86 F25 HORN
H759-A62 OR- 18 135-A88 BU- 16 200-A70 BK- 18 P981-A61 PU- 18 122-A82 RD- 16
FUSE C- 113-8490
P-C9 P987-P43 GN- 18 5 (14) ENGINE OIL 200-PA120 BK- 12 2 200-WT17 BK- 12 M733-WT4 PK- 14 P984-A113 YL- 18 144-A89 GN- 16 10A H758-A66 BR- 18 P983-A28 GN- 18 126-A84 PK- 18
87 30 113-8490
9X1054 327-P69 PK- 18 P991-P87 PK- 18 6 PRESSURE SWITCH(B) M906-WT13 BU- 14 10A 145-A1 BU- 18 H759-A62 OR- 18 P984-A57 YL- 18 128-A16 PK- 14
30 F16 AUX HYD ECM
86
1
5
109-P23 RD- 12
A347-P61 GN- 18
327-P68
327-P85
PK- 18
PK- 18 CONN 14 102-P2 RD- 14 1 1
405-E5 GY- 18 1

292-6568 CONN 16 87A (6) RELAY C-

781-A98 PK- 18 10A
113-8490 L998-A30 OR- 18
L999-A26 GN- 18
P984-A113 YL- 18
P987-A24 GN- 18 128-A49 PK- 18 40
(44) MAIN POWER A 30A 146-9439 A-C18
2 G798-P27 PU- 18 327-P74 PK- 18 782-A99 GY- 18 200-A86 BK- 18 L999-A65 GN- 18 P991-A63 PK- 18 128-A104 PK- 14
RELAY(B) 85 P-C5 (44) ROADING BREAKER (B) A-C16 F23 KEY SW 1733138
87 4 112-P10 PU- 12 A571-A115 PU- 14 200-A96 BK- 18 200-A81 BK- 16 F780-A7 PK- 18 42 PARKING BRAKE SW
115-1615 3 1779654 147-1773 A-C27 WT-C4 1733141 113-8490
87a 403-P50 GN- 18 403-P118 GN- 18 A751-A125 YL- 16 308-A109 YL- 18 10A A 112-A72 PU -12 P978-A29 GN- 18 200-A86 BK- 18
403-P119 GN- 18 112-P12 PU- 12 1 E-C5 3E5179 1552252 85 86
A752-A127 BR- 14 114-A79 RD- 18 A C 109-A74 RD -12 P979-A35 YL- 18 200-A96 BK- 18
2443926 F6 C2 QCPLR AUTOLVL
P-C16 112-P15 PU- 12 2 TO LOWER PLATFORM (14) COLD START THERMO 1 549-A114 PK- 18 128-A104 PK- 14 B GRAY P980-A25 OR- 18 122-A78 RD- 16 200-A70 BK- 18 45
87 30 113-8490 113-8490
9X1054 404-P22 YL- 18 112-P10 PU- 12 3 HARNESS A-C9 110-E14 GN- 18 1 TEMPERATURE SWITCH(B) C460-A56 BU- 14 2 C460-WT14 BU- 14 M907-WT10 GY- 14 10A C460-A56 BU- 14 614-A92 PU- 14 105-A76 RD- 16 C 10A P981-A61 PU- 18 122-A82 RD- 16
30 1 (LOC C-6)
109-P25 RD- 12 405-P34 GY- 18 109-P56 RD- 12 4 1

304-E11 WH- 12 G465-E15 PK- 18 2 238-8274 A571-A115 PU- 14 3 A571-WT15 PU- 14 P984-WT7 YL- 18
(6) RELAY C2 H758-A66 BR- 18 617-A93 BR- 18 117-A77 YL- 18 D P984-A57 YL- 18 122-A97 RD- 16 201-A2 BK- 16 G984-A8PK- 18 47 ARMREST SWITCH (N/C)
86 5
G S WT-C2 87A F22 A/C
(44) MAIN POWER B A347-P63 GN- 18 406-P33 PU- 18 A751-A125 YL- 16 4 A751-WT8 YL- 16 H759-A62 OR- 18 618-A94 YL- 18 125-A108 RD- 14 E P984-A113 YL- 18 126-A84 PK- 18 203-A51 BK- 18
RELAY(B) 85
2
4
G798-P46 PU- 18 436-P48 OR- 18 CONN 13 MTR BAT
1

101-E6 RD- 4
T
A752-A127 BR- 14 5 A752-WT16 BR- 14 1733141 146-9439 F5 SPARE
113-8491 H791-A100 GN- 18 118-A80 GY- 14 F 25A
124-3548
128-A49 PK- 18 203-A48 BK- 14
115-1615 87 112-P15 PU- 12 440-P72 BR- 18 H758-A66 BR- 18 6 H758-WT9 BR- 18 M907-WT10 GY- 14 A 15A H792-A101 BR- 18 122-A82 RD- 16 G 128-A104 PK- 14 203-A20 BK- 18
3 F15 WIPER WSHR
87a 447-P14 PK- 18 1

101-CC1 RD- 00 1 1

H759-A62 OR- 18 7 H759-WT6 OR- 18 782-WT11 GY- 18 B P984-A113 YL- 18 124-A107 RD- 14 H 200-A70 BK- 18
NEG E-C8 113-8491
604-P100 OR- 18 MOTOR
POS P984-A113 YL- 18 8 P984-WT7 YL- 18 C 781-A98 PK- 18 GRAY 15A 122-A97 RD- 16 200-A86 BK- 18 203-A17 BK- 14 52
P-C15 NOTE B 2364701 (14) COLD START PUMP ASSEMBLY 781-A98 PK- 18 9 781-WT12 PK- 18 D 122-A82 RD- 16 200-A96 BK- 18 306-A11 GN- 18 53
9X1054 SOLENOID(B) F24 MISC PWR
605-P55 YL- 18 1 782-A99 GY- 18 10 782-WT11 GY- 18 781-WT12 PK- 18 E 105-A76 RD- 16 782-A99 GY- 18 122-A78 RD- 16 306-A11 GN- 18 307-A67 OR- 18

57 2
6
22 A-T
95
30 (13) BATTERY (B) 113-8490

C
1 109-P24 RD- 12 606-P47 GY- 18 1

(50) STARTER(B) 249-7346 H791-A100 GN- 18 11 H791-WT3 GN- 18 F 85 86 109-A74 RD- 12 10A 126-A84 PK- 18 307-A67 OR- 18 674-A15 BU- 18
(44) MAIN POWER C 86 5 235-4963 153-5656 - 650 CCA F4 C1
A347-P73 GN- 18 617-P70 BR- 18 H792-A101 BR- 18 12 H792-WT5 BR- 18 G 110-A39 GN- 14 128-A49 PK- 18 674-A15 BU- 18 676-A3 PU- 18
2 230-6368 - 880 CCA 87 30 113-8490 F17 HEATER
RELAY(B) G798-P28 PU- 18 618-P71 YL- 18 M906-WT13 BU- 14 H 10A 112-A71 PU- 12 944-A50 OR- 18 128-A104 PK- 14 676-A3 PU- 18
85 113-8492
115-1615 87 4
3
112-P12 PU- 12 619-P54
779-P65
GN- 18
WH- 18 CBL-CA1 BK- 00
CONN 22 GRAY 87A (6) RELAY C1
112-A72 PU- 12
112-A73 PU- 12
945-A52 BR- 18 20A 200-A70 BK- 18
200-A81 BK- 16 944-A50 OR- 18
944-A22 OR- 18 G985-A9PU- 18 58 ARMREST SW (N/O)/ SEAT SW
87a (15) GLOW PLUGS (B) 146-9439
780-P64 PU- 18 877-E10 YL- 12 1

117-A77 YL- 18 A571-A115 PU- 14 200-A86 BK- 18 944-A59 OR- 18 944-A50 OR- 18 E918-A10 GN- 18 60 IMPL LOCKOUT SW
P-C4 A346-P42 BU- 18 107-3659 (6) FUSE BLOCK 2 118-A80 GY- 14 200-A96 BK- 18 945-A58 BR- 18 944-A59 OR- 18
(6) FUSE BLOCK 1
9X1054 "81.6A MAX 14.4A STEADY-STATE" 221-3881 119-A68 PK- 18 A751-A125 YL- 16 201-A2 BK- 16 945-A52 BR- 18 307-A67 OR- 18 62 KEY SW IN
30 1 CONNECTION PLATE 221-3880
109-P20 RD- 12 A347-P61 GN- 18 A347-P11 GN- 18 122-A78 RD- 16 945-A21 BR- 18
86 5 257-8390
(44) MAIN POWER A347-P76 GN- 18 A347-P63 GN- 18 123-A83 WH- 18 A752-A127 BR- 14 E918-A45 GN- 18 306-A11 GN- 18 64 START RELAY
D WKTL RELAY(B) 2 G798-P39 PU- 18 A347-P73 GN- 18 P-C2 124-A107 RD- 14 109-A74 RD- 12 203-A20 BK- 18 F780-A42 PK- 18 945-A52 BR- 18
85 4
246-9371 87 111-P16 YL- 12 A347-P76 GN- 18 1673693 PLATFORM AND ENGINE 125-A108 RD- 14 H758-A66 BR- 18 112-A72 PU- 12 203-A48 BK- 14 G982-A38 PK- 18 945-A58 BR- 18 G969-A13 YL- 18 66 RELAY RETURN
87a 3 102-P2 RD- 14 1
WORK TOOL ATTACHMENT HARNESSES 127-A85 OR- 18 203-A51 BK- 18 G984-A43 PK- 18 975-A14 WH- 18
C444-P66 YL- 18 105-P32 RD- 16 2 FOR MODELS 236 AND 252 128-A49 PK- 18 H759-A62 OR- 18 306-A11 GN- 18 G985-A44 PU- 18 975-A14 WH- 18 68 COMMON
117-P105 YL- 18 3 134-A87 YL- 16 307-A67 OR- 18 H758-A66 BR- 18
F905-P112 YL- 18 F905-P44 YL- 18 118-P57 GY- 14 4 135-A88 BU- 16 P984-A113 YL- 18 A-C13 CAP 676-A3 PU- 18 H759-A62 OR- 18 975-A47 WH- 18 674-A15 BU- 18 70 PARKING BRAKE LAMP
F905-P113 YL- 18 119-P3 PK- 18 5 144-A89 GN- 16 9W1951 8C-6354 674-A15 BU- 18 L998-A30 OR- 18 975-A46 WH- 18
TO HVAC UNIT
6 102-PA2 RD- 14 A-C8 200-A110 BK- 14 122-A97 RD- 16 A 944-A50 OR- 18 L999-A26 GN- 18
G798-P27 PU- 18 122-P128 RD- 16 7 306-A11 GN- 18 200-A96 BK- 18 B SERVICE CONNECTOR 944-A59 OR- 18 L999-A65 GN- 18 A958-A4 WH- 18 A-C5 (47) AUXILIARY HYDRAULIC CONTROL
1552272 1506765
G798-P28 PU- 18 G798-P17 PU- 18 123-P92 WH- 18 8 111-PA16 YL- 12 307-A67 OR- 18 C PIN DESCRIPTION 945-A52 BR- 18 M901-A23YL- 18
G798-P39 PU- 18 127-P31 OR- 18 9 109-PA23 RD- 12 200-PA120 BK- 12
1 200-A110 BK- 14 308-A109 YL- 18 944-A50 OR- 18 D 945-A58 BR- 18 P978-A29 GN- 18 128-A16 PK- 14 1 + BATTERY
2 308-A109 YL- 18 A POWER
G798-P46 PU- 18 128-P5 PK- 18 10 109-PA25 RD- 12 308-A109 YL- 18 945-A52 BR- 18 E 975-A46 WH- 18 P979-A35 YL- 18 E918-A10 GN- 18
(54) HYDRAULIC FILTER 436-P48 OR- 18 134-P26 YL- 16 11
3 124-A107 RD- 14 321-A55 BR- 18 F
B GROUND 975-A47 WH- 18 P980-A25 OR- 18 E918-A32 GN- 18 203-A17 BK- 14 3 GROUND
K927-P90 BU- 18 K927-P67 BU- 18 135-P21 BU- 16 203-PA127 BK- 18
4 125-A108 RD- 14 322-A53 GY- 18 NOTE A D CAT DATA LINK POS (+) A958-A4 WH- 18 P981-A60 PU- 18
BYPASS SWITCH (B) 12 1

G
134-0404 K927-P107 BU- 18 144-P18 GN- 16
307-P9 OR- 18
13
14
109-PA38 RD- 8
STRAP CAB GND
CONN 20 614-A92 PU- 14
617-A93 BR- 18
H
J
E CAT DATA LINK NEG (-) E918-A45 GN- 18
F780-A42 PK- 18
P981-A61 PU- 18
P983-A28 GN- 18
E918-A45 GN- 18 P981-A18 PU- 18 5 TWO SPEED/BOOST FLOW

L987-P62 WH- 18 404-P22 YL- 18 15 109-PA53 RD- 8 ASSEMBLE 7G-1060 PA-C14 A-C11 618-A94 YL- 18 G969-A13 YL- 18 P984-A57 YL- 18 F780-A7 PK- 18 P993-A19 OR- 18 7 CONTINUOUS FLOW SW
CAB GND
M732-P1 OR- 18 405-P34 GY- 18
406-P33 PU- 18
16
17 109-PA20 RD- 12
STRAP CAB GND
FROM BOSS ON 105-PA32 RD- 16
1673693
1
1673692
105-A76 RD- 16
674-A15 BU- 18
676-A3 PU- 18
CONN 31 G982-A38 PK- 18
G984-A43 PK- 18
P984-A113 YL- 18
P987-A24 GN- 18
F780-A31 PK- 18
P991-A63 PK- 18 9 MODE SELECT (AUX FLOW)
436-P48 OR- 18 18 TO CAB 109-PA24 RD- 12 UPPER FRAME AS. NOTE B 110-PA98 GN- 18 2 110-A39 GN- 14 944-A59 OR- 18 G985-A44 PU- 18 P991-A63 PK- 18 F780-A42 PK- 18
200-P80 BK- 16 440-P72 BR- 18 19 HARNESS C-C21 TO CAB GND 117-PA105 YL- 18 3 117-A77 YL- 18 945-A58 BR- 18 H416-A6 GN- 18 G969-A13 YL- 18 945-A21 BR- 18 11 - CDL
C444-P66 YL- 18 20 (VOL 2, LOC E-9) 110-PA58 GN- 18 118-PA57 GY- 14 4 118-A80 GY- 14 A751-A125 YL- 16 (6) POWER SOCKET L998-A30 OR- 18 G982-A38 PK- 18
447-P14 PK- 18 21 OR CN-C21 110-PA98 GN- 18 119-PA3 PK- 18 5 119-A68 PK- 18 A752-A127 BR- 14 145-A1 BU- 18 1

178-7539 L999-A26 GN- 18 G984-A43 PK- 18 944-A22 OR- 18 13 + CDL

(11) UPPER FRAME GROUND 200-P106 BK- 14 614-P75 PU- 14 22 (VOl 2, LOC E-7) 110-PA102 GN- 18 105-PA32 RD- 16 122-PA91 RD- 16 6 122-A78 RD- 16 E918-A45 GN- 18 200-A86 BK- 18 L999-A65 GN- 18
10A
1 1

STUD (B) 674-P29 BU- 18 23 109-PA56 RD- 12 123-PA92 WH- 18 7 123-A83 WH- 18 F780-A42 PK- 18 M901-A23YL- 18 G984-A8PK- 18
676-P30 PU- 18 24 PA-C18 110-PA98 GN- 18 127-PA31 OR- 18 8 127-A85 OR- 18 G982-A38 PK- 18 P978-A29 GN- 18 G984-A41 PK- 18 NOTE A
1

200-P120 BK- 12 A751-P8 YL- 16 25 1552267 111-PA16 YL- 12 112-PA10 PU- 12 128-PA5 PK- 18 9 128-A49 PK- 18 G984-A43 PK- 18 P979-A35 YL- 18
NOTE B A752-P129 BR- 14 26 (51) HYDRAULIC OIL A 112-PA10 PU- 12 112-PA12 PU- 12 134-PA26 YL- 16 10 134-A87 YL- 16 G985-A44 PU- 18 P980-A25 OR- 18 G985-A44 PU- 18 M901-A23YL- 18 18 INTERLOCK OVERRIDE LAMP
779-P65 WH- 18 27
TEMPERATURE SWITCH(A) WH-16 B 404-PA22 YL- 18 112-PA12 PU- 12 112-PA15 PU- 12 135-PA21 BU- 16 11 135-A88 BU- 16 M901-A23YL- 18 P981-A60 PU- 18 P987-A24 GN- 18 19 AUX BLEED OFF SW
780-P64 PU- 18 28 BK-16 C 200-PA84 BK- 18 112-PA15 PU- 12 117-PA105 YL- 18 144-PA18 GN- 16 12 144-A89 GN- 16 P981-A60 PU- 18 P981-A61 PU- 18 200-A81 BK- 16 G985-A9PU- 18
F780-P35 PK- 18 29
236-1872 118-PA57 GY- 14 306-PA59 GN- 18 13 306-A11 GN- 18 P983-A28 GN- 18 P982-A27 BU- 18 200-A110 BK- 14 G985-A40 PU- 18
T
M901-P36 YL- 18 30 122-PA51 RD- 18 119-PA3 PK- 18 307-PA9 OR- 18 14 307-A67 OR- 18 P987-A24 GN- 18 P983-A28 GN- 18 201-A2 BK- 16
F905-P44 YL- 18 31 122-PA128 RD- 18 122-PA91 RD- 16 308-PA95 YL- 18 15 308-A109 YL- 18 P991-A63 PK- 18 P984-A57 YL- 18 203-A48 BK- 14 H416-A6 GN- 18
(12) FUEL LEVEL SENDER (A) PA-C13 122-PA91 RD- 16 123-PA92 WH- 18 321-PA7 BR- 18 16 321-A55 BR- 18 P984-A75 YL- 18 203-A51 BK- 18 L998-A30 OR- 18 P980-A25 OR- 18 24 CTRL SOL/PRESS SOL
(52) VALVE DVTR XR XRMTL SOLENOID(B) (52) VALVE DVTR ARC MTL SOLENOID(B) CONN 12 224-8544 - BETA SSL
231-2105 - ALPHA SSL
1552269 127-PA31 OR- 18 322-PA19 GY- 18 17 322-A53 GY- 18 P986-A37 PU- 18 549-A114 PK- 18 L999-A64 GN- 18
223-8418 224-9408 PK-18 1 447-PA14 PK- 18 200-PA80 BK- 16 128-PA5 PK- 18 614-PA75 PU- 14 18 614-A92 PU- 14 P987-A24 GN- 18 975-A47 WH- 18 L999-A64 GN- 18 26 H SOLENOID SOURCE
105-P32 RD- 16 P-C8 231-2106 - 247/257 BK-18 2 200-PA83 BK- 18 200-PA4 BK- 18 134-PA26 YL- 16 617-PA70 BR- 18 19 617-A93 BR- 18 P988-A5 OR- 18 A958-A4 WH- 18 L999-A26 GN- 18
P-C22 117-P105 YL- 18 1552252 200-PA82 BK- 18 135-PA21 BU- 16 618-PA71 YL- 18 20 618-A94 YL- 18 P991-A63 PK- 18 C460-A56 BU- 14 L999-A65 GN- 18
RD-18 1 1552272 118-P57 GY- 14 403-P118 GN- 18 1 200-PA84 BK- 18 144-PA18 GN- 16 674-PA29 BU- 18 21 674-A15 BU- 18 P993-A19 OR- 18 G969-A13 YL- 18 M901-A23YL- 18 P982-A27 BU- 18 29 TWO SPEED SWITCH
2 RD-18 1 F905-P112 YL- 18 119-P3 PK- 18 E918-P37 GN- 18 2 200-PA83 BK- 18 306-PA59 GN- 18 676-PA30 PU- 18 22 676-A3 PU- 18 P994-A36 BU- 18 H791-A100 GN- 18 P978-A29 GN- 18
RD-18 3 2 F905-P113 YL- 18 123-P92 WH- 18 K927-P67 BU- 18 3 200-PA103 BK- 18 307-PA9 OR- 18 F780-PA35 PK- 18 23 F780-A42 PK- 18 P996-A34 GN- 18 H792-A101 BR- 18 P979-A35 YL- 18 P983-A28 GN- 18 31 MODE SELECT
4 RD-18 3 200-P110 BK- 18 127-P31 OR- 18 P981-P6 PU- 18 4 HE-C2 HE-C1 PA-C12 308-PA95 YL- 18 M901-PA36 YL- 18 24 M901-A23YL- 18 P997-A33 BR- 18 P984-A75 YL- 18 P980-A25 OR- 18 (XPS/HIGH FLOW)
4 200-P111 BK- 18 128-P5 PK- 18 G982-P40 PK- 18 5 TO CAB 1552269 3E3364 1552269 321-PA7 BR- 18 E918-PA37 GN- 18 25 E918-A45 GN- 18 P986-A37 PU- 18 P981-A18 PU- 18
134-P26 YL- 16 P983-P60 GN- 18 6 HARNESS C-C24 (51) FORWARD HORN (A) 1 322-HE1 GY-18 1 322-PA19 GY- 18 200-PA106 BK- 18 322-PA19 GY- 18 944-PA81 OR- 18 26 944-A59 OR- 18 P988-A5 OR- 18
135-P21 BU- 16 G984-P45 PK- 18 7 (VOL 2, LOC D-9) 164-9425 2 200-HE2 BK-18 2 200-PA82 BK- 18 200-PA13 BK- 18 614-PA75 PU- 14 945-PA77 BR- 18 27 945-A58 BR- 18 A-C7 P994-A36 BU- 18 P981-A60 PU- 18
144-P18 GN- 16 G985-P49 PU- 18 8 OR CN-C24 "12 V 5.4A" 200-PA89 BK- 18 617-PA70 BR- 18 28 P981-A60 PU- 18 1552269 P996-A34 GN- 18 P981-A61 PU- 18

WC-C2
306-P59 GN- 18 L987-P62 WH- 18 9 (VOL 2, LOC D-7) CONN 17 200-PA74 BK- 18 618-PA71 YL- 18 G982-PA40 PK- 18 29 G982-A38 PK- 18 P981-A61 PU- 18 1 (8) TWO SPEED SOL ALTERNATE MATING P997-A33 BR- 18
614-P75 PU- 14 P987-P43 GN- 18 10 200-PA79 BK- 18 674-PA29 BU- 18 P983-PA60 GN- 18 30 P983-A28 GN- 18 L999-A65 GN- 18 2 216-0610 CONN FW-C6 AT P982-A27 BU- 18
1552269 674-P29 BU- 18 P991-P87 PK- 18 11 200-PA6 BK- 18 676-PA30 PU- 18 G984-PA45 PK- 18 31 G984-A43 PK- 18 1.33A VOL 1, LOC C-4 P983-A28 GN- 18
1 WC-1 YL-16 WC-C1 P-C11 676-P30 PU- 18 308-P94 YL- 18 12 944-PA81 OR- 18 P984-A69 YL- 18 P978-A29 GN- 18 40 A1 SOLENOID
NOTE A
COIL S-1 2 WC-2 BK-16
WC-1 YL-16
3E3376
1
1552272
779-P65 WH- 18
944-P81 OR- 18
945-P77 BR- 18 CONN 11
945-PA77 BR- 18
A751-PA8 YL- 16
CONN 15 TW0-SPEED SOL (ATCH) P984-A57 YL- 18 L998-A30 OR- 18 42 A SOLENOID SOURCE
WC-C3
1552269
WC-2 BK-16
WC-3 BK-16
2
3
K927-P107 BU- 18
K927-P90 BU- 18
A751-P8 YL- 16
A752-P129 BR- 14
P-C24
2 SP JUMPER 200-PA120 BK- 12
A752-PA129 BR- 14
E918-PA37 GN- 18 PA-C1
1552273
A-C1
3E3382
NOTE L
A-C24
1552269
FOR MODELS 236, 246, P984-A75 YL- 18

1 WC-4 RD-16 WC-4 RD-16 4 780-P64 PU- 18 E918-P37 GN- 18 133-9931 F780-PA35 PK- 18 (8) A1 SOLENOID P986-A37 PU- 18 F780-A31 PK- 18 45 PARKING BRAKE SWITCH
COIL S-2 2 WC-3 BK-16 F780-P35 PK- 18 1552267 203-PA116 BK- 18 G982-PA40 PK- 18 1 P978-A29 GN- 18 1 185-4254 252, 262, 248, 268 P987-A24 GN- 18

(53) QUICK COUPLER SOLENOID (B) CONN 1 G982-P40 PK- 18

G984-P45 PK- 18
P981-P41 PU- 18 A
B
BK-18
NOTE P
PA-C9
9X1054
203-PA78 BK- 18
203-PA127 BK- 18
G984-PA45 PK- 18
G985-PA49 PU- 18
A751-PA8 YL- 16
A752-PA129 BR- 14
2
3
A751-A125 YL- 16
A752-A127 BR- 14
L998-A91 OR- 18 2 1.7A P988-A5 OR- 18
P991-A63 PK- 18
E918-A32 GN- 18 47 IMPLEMENT LOCKOUT SWITCH

233-7128 30 1 G985-A44 PU- 18 A-C25 (6) RELAY HIGH FLOW (A)

G985-P49 PU- 18 P981-P6 PU- 18 C BK-18 109-PA23 RD- 12 M901-PA36 YL- 18 G985-PA49 PU- 18 4 P993-A19 OR- 18
86 5 P987-A24 GN- 18 1552269 FW-C5
"0.92 A MIN, 1.2 A CONT" M901-P36 YL- 18 (44) MAIN POWER A A347-PA61 GN- 18 308-PA93 YL- 18 P983-PA60 GN- 18 P987-PA43 GN- 18 5 115-1615 120-FW15YL- 18 P994-A36 BU- 18
P-C23 2 P991-A63 PK- 18 (8) A2 SOLENOID 9X1054 FW-C1
1003320
P981-P6 PU- 18
P981-P41 PU- 18 CONN 10 RELAY(A)
115-1615
85
87 4
G798-PA27 PU- 18
112-PA10 PU- 12
308-PA94 YL- 18
308-PA95 YL- 18
P987-PA43 GN- 18
P991-PA87 PK- 18
P991-PA87 PK- 18 6 P979-A35 YL- 18
L998-A95 OR- 18
1
2 185-4254 30
86
1 120-FW15YL- 18 1552269
P996-A34 GN- 18
P997-A33 BR- 18 P997-A33 BR- 18 52 PROPORTIONAL "A" SNSR RET
A
B
440-P72 BR- 18
200-P114 BK- 18
P983-P60 GN- 18
P987-P43 GN- 18
87a 3
PA-C16
308-PA117 YL- 18 CONN 14 L998-A30 OR- 18
1.7A 5
2
L999-FW2GN- 18
P980-FW8OR- 18
H758-FW3BR- 18
200-FW4BK- 18
1
2
(8) SOLENOID (C+) HIGH FLOW(A)
231-0295
P996-A34 GN- 18 53 PROPORTIONAL SIGNAL
85 (19) RH HANDLE AS OPT
P991-P87 PK- 18 9X1054 321-PA7 BR- 18 87 4 Y905-FW10YL- 18 120-FW12YL- 18
30 3 218-6118 (REXROTH)
1 109-PA25 RD- 12 322-PA19 GY- 18 87a 120-FW13YL- 18
86 PA-C5 A-C9 A-C22 SYMBOL ORIENTED ACCORDING TO OPERATOR USAGE;
(44) AIR FILTER INDICATOR SWITCH(B) (45) MAIN POWER B 5 A347-PA63 GN- 18 200-FW11 BK- 18 MACHINE FORWARD CORRESPONDS TO RIGHT SIDE OF
P-C10 2 1779654 1779649 1552264 FW-C7 FW-C2 P979-A35 YL- 18 58 A2 SOLENOID
237-7325 RELAY(A) G798-PA46 PU- 18 403-PA50 GN- 18 DIAGRAM SHEET
3E3376 85 4 112-PA12 PU- 12 1 112-A71 PU- 12 3E3388 1552269
"75 mbar; 6 W" 105-P32 RD- 16 115-1615 87 112-PA15 PU- 12 403-PA119 GN- 18 H758-A66 BR- 18 1 200-FW4BK- 18
TO CAB 3 112-PA15 PU- 12 2 112-A72 PU- 12 200-A70 BK- 18 2 TO HIGH FLOW ATCH 1 H758-FW3BR- 18 200-FW5BK- 18 H759-FW6OR- 18 1 (8) SOLENOID (C-) HIGH FLOW(A) P994-A36 BU- 18 60 PROPORTIONAL +8V SUPPLY
117-P105 YL- 18 1
87a 403-PA118 GN- 18
HARNESS C-C25 112-PA10 PU- 12 3 112-A73 PU- 12
118-P57 GY- 14 605-P55 YL- 18 2 120-A117 YL- 18 3 HARN FW-C7 2 200-FW11 BK- 18 200-FW14BK- 18 200-FW5BK- 18 2 231-0295 WORKTOOL
P-C20 (VOL 2, LOC D-9) 109-PA56 RD- 12 4 109-A74 RD- 12
119-P3 PK- 18 606-P47 GY- 18 3 PA-C15 404-PA22 YL- 18 H759-A62 OR- 18 4 (VOL 1, LOC C-4) OR TO 3 120-FW13YL- 18
1 PLUGGED "A2" P986-A37 PU- 18 62 A1 SWITCH/PRESS SW NC
(11) FUEL PRIME PUMP MOTOR (B) 1
1552269
327-P69 PK- 18
123-P92 WH- 18
127-P31 OR- 18
619-P54 GN- 18 4 CONN 9 30 1
9X1054
109-PA24 RD- 12
436-PA48
440-PA72
OR- 18
BR- 18 CONN 13
L999-A26 GN- 18
P980-A25 OR- 18
5
6
HIGH FLOW XPS ATCH
HARN FL-C7
TO LOWER PLATF
HARN A-C22
4
5
H759-FW6OR- 18
L999-FW7GN- 18
H758-FW3BR- 18
H759-FW6OR- 18 FW-C3 2 BR-20
G982-A38 PK- 18 64 INTERLOCK OVERRIDE SWITCH
232-5877 86 5 (VOL 1, LOC C-4) P980-FW8OR- 18 1552269 3 YL-20
2 200-P109 BK- 18 128-P5 PK- 18 (45) MAIN POWER C A347-PA73 GN- 18 447-PA14 PK- 18 P984-A57 YL- 18 7 (VOL 1, LOC D-6) 6
4 PLUGGED
"4.5 A STATIC" 134-P26 YL- 16 2 G798-PA28 PU- 18 604-PA100 OR- 18 P984-A113 YL- 18 8 7 P984-FW9YL- 18 L999-FW7GN- 18 Y905-FW10YL- 18 1 (8) HIGH FLOW SOLENOID P984-A69 YL- 18 66 CONTROL +/- PRESS SW NO
RELAY(A) 85 5 PLUGGED
PUMP GP FUEL PRM 135-P21 BU- 16 115-1615 4 112-PA12 PU- 12 PA-C2 8 P984-FW9YL- 18 P981-FW1PU- 18 200-FW14BK- 18 2 231-0295
144-P18 GN- 16 P-C25
1552252
P-C26
3E5179
87
87a 3 605-PA55 YL- 18 1673693 CONN 30 CONN 30 Y905-FW10YL- 18 (39) LOWER PLATF GND 6
7
PLUGGED
PLUGGED
G985-A40 PU- 18 68 ARMREST SW (N/0)/SEATSW
306-P59 GN- 18 NOTE J 606-PA47 GY- 18 102-PA2 RD- 14 1
8 PLUGGED
FW-C8
614-P75 PU- 14
674-P29 BU- 18
122-P51
203-P116
RD- 18
BK- 18
1
2 203-P121 BK- 18 PA-C4
617-PA70
618-PA71
BR- 18
YL- 18
105-PA32 RD- 16
117-PA105 YL- 18
2
3 LOWER PLATFORM TO RH POD
HARN RA-C6
1552269
200-A81 BK- 16
200-A110 BK- 14
9
10
PLUGGED
PLUGGED
G984-A41 PK- 18 70 ARMREST SW (N/C)

676-P30 PU- 18 945-P77 BR- 18 3 9X1054 619-PA54 GN- 18 118-PA57 GY- 14 4 (VOL 1, LOC B-4) 1 120-FW12YL- 18 201-A2 BK- 16
P-C3 30 1 2 (8) CONTINUOUS FLOW SOLENOID 11 OR-20
944-P81 OR- 18 944-P81 OR- 18 4
(45) MAIN POWER D WKTL 109-PA20 RD- 12 779-PA65 WH- 18 119-PA3 PK- 18 5 203-A48 BK- 14 AUXILIARY HYDRAULIC CONT
1552269 86 5 FW-C4 231-0295 12 YL/BU-20
216-0658
1 327-P68 PK- 18
945-P77 BR- 18
A751-P8 YL- 16
308-P117
403-P119
YL- 18
GN- 18
5
6
308-P123 YL- 18 RELAY(A)
85
2
A347-PA76 GN- 18
G798-PA39 PU- 18
780-PA64 PU- 18
122-PA128 RD- 18
6
7 CONN 28 1552269 WORKTOOL
"A1"
246-9371 4 PLATFORM AND ENGINE FW-C6 P981-FW1PU- 18
2 307-P52 OR- 18 A752-P129 BR- 14 G798-P17 PU- 18 7 203-P124 BK- 18 87 111-PA16 YL- 12 A347-PA11 GN- 18 123-PA92 WH- 18 8 TO LOWER PLATF 1
E918-P37 GN- 18 A347-P11 GN- 18 8 308-P123 YL- 18 87a 3 127-PA31 OR- 18 9 FOR MODELS 216, 226, 232, 242, 247, 257 HARN A-C7 3E3364 L999-FW7GN- 18 2 NOTE B (19) RH HANDLE
SUPPR ARC F PUMP F780-P35 PK- 18 203-P78 BK- 18 9 203-P124 BK- 18 A347-PA61 GN- 18 128-PA5 PK- 18 10 (VOL 1, LOC E-5) 1 P981-FW1PU- 18 215-8308 (ITT)
106-8704 G982-P40 PK- 18 306-P59 GN- 18 10 306-P122 GN- 18 A347-PA63 GN- 18 134-PA26 YL- 16 11 EA-C7 2 L999-FW2GN- 18
1552272 A-C2 215-8307 - ROLLER/WKTL TRIGGER ONLY (ITT)
MUR460 G984-P45 PK- 18 A346-P42 BU- 18 11 306-P122 GN- 18 A347-PA73 GN- 18 135-PA21 BU- 16 12 "60 mA MAX"
P-C6
G985-P49 PU- 18 M732-P1 OR- 18 12 203-P121 BK- 18 A347-PA76 GN- 18 144-PA18 GN- 16 13 TO CAB 308-EA29 YL- 18 1
TO COLD START CONN 29 HIGH FLOW (ATCH) 1552269
(39) SOLENOID PARKING BRAKE SYMBOL ORIENTED ACCORDING TO OPERATOR USAGE; (19) RH HANDLE OPTION
M901-P36 YL- 18 307-PA9 OR- 18 14 HARNESS C-C21 200-EA12 BK- 18 2
EG-C1 A958-A4 WH- 18 1
MACHINE FORWARD CORRESPONDS TO RIGHT SIDE OF DIAGRAM
247-6462
30 1
1195094
110-P86 GN- 18
P981-P6 PU- 18
P981-P41 PU- 18
CONN 8 F905-PA44
F905-PA68
YL- 18
YL- 18
404-PA22 YL- 18
405-PA34 GY- 18
15
16
(VOL 2, LOC E-9)
OR CN-C21
L987-EA17 WH- 18
304-EA32 WH- 18
3
4
(VOL 1, LOC B-4)
FOR MODELS 226, 242, 257 G969-A13 YL- 18 2
1.5A SHEET 223-3725 (ITT)
SYMBOL ORIENTED ACCORDING TO OPERATOR
86 (VOL 2, LOC E-7) R-C5 USAGE; MACHINE FORWARD CORRESPONDS TO
(11) FUEL PUMP RELAY 5 327-P85 PK- 18 P983-P60 GN- 18 F905-PA69 YL- 18 406-PA33 PU- 18 17
EA-C20 1552252 ROLLER - PROPORTIONAL A1 / A2 RIGHT SIDE OF DIAGRAM SHEET
115-1615 2 200-P88 BK- 18 P987-P43 GN- 18 436-PA48 OR- 18 18
85
87 4 327-P74 PK- 18 P991-P87 PK- 18 440-PA72 BR- 18 19 CONN 12 1779646 TO COLD START P994-R2 BU- 18 1 WH-20 POWER
GROUND
87a 3 C444-PA66 YL- 18 20 109-EA19 RD- 12 1 EG-C3 P997-R9 BR- 18 2 BR-20 <--- A1 A2 ---> WORKTOOL WORKTOOL
(13) HYDRAULIC FILTER ROLLER SIGNAL
1

436-PA48 OR- 18 447-PA14 PK- 18 21 877-EA10 YL- 12 2 (VOL 1, LOC B-4) ALTERNATE MATING 203-R15 BK- 18 P996-R1 GN- 18 3 YL-20 CALIBRATION "A2" "A1"
P-C21 BYPASS SWITCH (A) CONN RA-C1 AT 549-R16 PK- 18 4 VI-20 1 PLUGGED
G798-PA17 PU- 18 614-PA75 PU- 14 22
1552267 134-0404 674-PA29 BU- 18 23 VOL 1, LOC A-4 5 DK GN-20 2 BR-20
TO STOP LAMP SW ATCH A 110-P102 GN- 18 G798-PA27 PU- 18 676-PA30 PU- 18 24 EA-C6 975-R6 WH- 18 975-R14 WH- 18 6 DK BU-20 WORKTOOL 3 YL-20
HARNESS G-C1 B 200-P108 BK- 18 G798-PA28 PU- 18 A751-PA8 YL- 16 25 9X1054 A-C6 R-C1 975-R13 WH- 18 203-R15 BK- 18 7 LT GN-20 TRIGGER 4 PLUGGED
30 1552252 3E5179 8 5 PLUGGED
(VOL 2, LOC D-3) C 604-P100 OR- 18 G798-PA39 PU- 18 A752-PA129 BR- 14 26 109-EA18 RD- 12 1
86 EG-C1 LT BU-20
G798-PA46 PU- 18 779-PA65 WH- 18 27 A346-EA16 BU- 18 5 3E3376 (45) COLD START RELAY(A) 549-A114 PK- 18 1 549-R16 PK- 18 P986-R7 PU- 18 9 T-20 6 PLUGGED
CONN 5 780-PA64 PU- 18 28 M732-EA13 OR- 18 2
85
(45) START RELAY (A)
TO PLATFORM 1 EG-C2 115-1615 203-A51 BK- 18 2 203-R15 BK- 18 549-R16 PK- 18 10 GY-20 WORKTOOL 7 PLUGGED
PLATFORM AND ENGINE F780-PA35 PK- 18 29 304-EA31 WH- 12 4
87
115-1615 AND ENGINE 2 200-EG3 BK- 18 9X1054 C460-A56 BU- 14 3 P988-R5 OR- 18 P988-R12 OR- 18 P986-R7 PU- 18 11 OR-20 "C+" 8 PLUGGED
K927-PA67 BU- 18 M901-PA36 YL- 18 30 3 30 975-A47 WH- 18 4 975-R6 WH- 18 P988-R11 OR- 18 P997-R8 BR- 18 12 PLUGGED WORKTOOL 9 PLUGGED
FOR MODELS 236 AND 252 K927-PA41 BU- 18 F905-PA44 YL- 18 31
87a EA-C7 3 L987-EG2 WH- 18 109-EG1 RD- 12 1
86 P984-A75 YL- 18 5 "C-" 10 PLUGGED
(VOL 1, LOC C-5)
NOTE C
K927-PA52 BU- 18
4 L987-EG2 WH- 18
200-EG3 BK- 18
5
2
85
P986-A37 PU- 18
P988-A5 OR- 18
6
7
P986-R7 PU- 18
P988-R5 OR- 18
P994-R2 BU- 18
P996-R1 GN- 18
CONN 33 11
12
OR-20
YL/BU-20
877-EG4 YL- 12 4
110-EA1 GN- 18 EA-C10 87 P994-A36 BU- 18 8 P994-R2 BU- 18 P997-R9 BR- 18
H-C1 P-C17 EG-C3 3 R-C2
PA-C8 200-EA4 BK- 18 1552269 87a P996-A34 GN- 18 9 P996-R1 GN- 18 P997-R3 BR- 18 P997-R8 BR- 18
3E3388 1552264 TO PLATFORM 1779641 1552269
1552252 C444-EA30 YL- 18 1 P997-A33 BR- 18 10 P997-R3 BR- 18
AND ENGINE 1 109-EG1 RD- 12 (19) COIL ASSEMBLY FERRITE
200-H5 BK- 16 1 200-P103 BK- 16 403-PA118 GN- 18 1 200-EA2 BK- 18 308-EA28 YL- 18 2 H791-A100 GN- 18 11 P988-R12 OR- 18 1
EA-C20 2 877-EG4 YL- 12 172-0970
321-H11 BR- 18 2 321-P7 BR- 18 1

200-PA80 BK- 16 E918-PA37 GN- 18 2 DIODE BLOCKING H792-A101 BR- 18 12 975-R14 WH- 18 2
(VOL 1, LOC C-5) "12V 1.1A"
604-H12 OR- 18 3 604-P100 OR- 18 K927-PA67 BU- 18 3 200-EA12 BK- 18 106-8704
605-H4 YL- 18
606-H7 GY- 18
4
5
605-P55 YL- 18
606-P47 GY- 18
(51) GROUND UPPER FRAME
1

200-PA106 BK- 18 105-PA32 RD- 16

109-PA56 RD- 12 G982-PA40 PK- 18
4
5 TO CAB
200-EA14
200-EA24
BK- 18
BK- 18
MUR460 CONN 27 R-C4
1552269
STUD (A) EA-C2 P988-R11 OR- 18
(19) IMPLEMENT PILOT SOLENOID
617-H3 BR- 18 6 617-P70 BR- 18 117-PA105 YL- 18 P983-PA60 GN- 18 6 HARNESS C-C24 200-EA25 BK- 18 1
618-H8 YL- 18 7 618-P71 YL- 18 1

200-PA120 BK- 12 118-PA57 GY- 14 G984-PA45 PK- 18 7 (VOL 2, LOC D-9) 1552269 COLD START RELAY JUMPER 975-R13 WH- 18 2 195-9700
PA-C7 EA-C1 "0.78A MIN 1.11A CONTINUOUS"
8 619-P54 GN- 18 NOTE B 119-PA3 PK- 18 G985-PA49 PU- 18 8 OR CN-C24 304-EA11 WH- 12 C444-EA27 YL- 18 1 (14) DMML ALTERNATOR RESISTOR(A)
123-PA92 WH- 18 L987-PA62 WH- 18 9 (VOL 2, LOC D-7) 1552252 3E5179 304-EA31 WH- 12 C444-EA30 YL- 18 2 238-9397
CONN 4 127-PA31 OR- 18 P987-PA43 GN- 18 10 110-PA58 GN- 18 1 110-EA1 GN- 18 304-EA32 WH- 18 LOWER PLATFORM
NOTE C 128-PA5 PK- 18 P991-PA87 PK- 18 11 CONN 11 200-PA89 BK- 18 2 200-EA4 BK- 18
134-PA26 YL- 16 308-PA94 YL- 18 12 200-PA13 BK- 18 3 200-EA2 BK- 18 308-EA8 YL- 18 IDENT PART NO. CHG NOTE ATCH DESCRIPTION
PA-C17 135-PA21 BU- 16 308-PA93 YL- 18 4 308-EA8 YL- 18 304-EA11 WH- 12
1552264 144-PA18 GN- 16 C444-PA66 YL- 18 5 C444-EA9 YL- 18 308-EA28 YL- 18 HARNESS AS - COMMON
1 200-PA103 BK- 18 306-PA59 GN- 18 A346-PA42 BU- 18 6 A346-EA16 BU- 18 308-EA29 YL- 18
TO REAR DOOR
2 321-PA7 BR- 18 307-PA9 OR- 18 403-PA50 GN- 18 7 403-EA7 GN- 18
C 216-4752 07 OPT CAB - EAME ONLY
LJ-C2 LJ-C1 H-C2 HARNESS H-C1
KENR8654-03 VOL 1 of 2

PA-C10
1552272 3E3376 1552272 (VOL 1, LOC B-9) 3 604-PA100 OR- 18 405-PA34 GY- 18
3E3376
405-PA34 GY- 18 8 405-EA5 GY- 18 403-EA7 GN- 18 F 272-1626 03 ATCH DEMAND FAN
OR ROADING LAMP 4 605-PA55 YL- 18 406-PA33 PU- 18 406-PA33 PU- 18 9 406-EA3 PU- 18 405-EA5 GY- 18 (14) ALTERNATOR(A)
TURN YL 1 605-LJ1 YL- 18 1 TO REAR DOOR
TAIL
1 605-H4 YL- 18 200-H1 BK- 18 HARNESS KJ-C2 5 606-PA47 GY- 18 614-PA75 PU- 14 1 TO CAB L987-PA62 WH- 18 10 L987-EA17 WH- 18 406-EA3 PU- 18 225-3143 G 216-4711 04 ATCH STOP LAMP SW
GND WH 2 200-LJ2 BK- 18 200-LJ5 BK- 18 2 HARNESS H-C2 WH 2 200-H1 BK- 18 (VOL 2, LOC E-3) 6 617-PA70 BR- 18 674-PA29 BU- 18 605-PA55 YL- 18 2 HARNESS C-C25 M732-PA1 OR- 18 11 M732-EA13 OR- 18 877-EA10 YL- 12 "12V 85A"
STOP RD 3 604-LJ3 OR- 18 3 (LOC B-8) RD 3 604-H9 OR- 18 200-H6 BK- 18 7 618-PA71 YL- 18 676-PA30 PU- 18 606-PA47 GY- 18 3 (VOL 2, LOC D-9) 12 H 216-4703 04 REAR DOOR
TAIL BK 4 617-LJ4 BR- 18 617-LJ6 BR- 18 4 BK 4 617-H3 BR- 18 200-H10 BK- 18 8 619-PA54 GN- 18 944-PA81 OR- 18 619-PA54 GN- 18 4 J 233-5824 01 ATCH DUAL CONT - BKUP ALM
NOTE E
STOP
CONN 4 945-PA77 BR- 18 CONN 9 CONN 21 A309-EA15 GY- 18 C444-EA26 YL- 18 1

D+
(16) LAMP GROUP SIGNAL CONN 3 200-H5 BK- 16 A346-PA42 BU- 18 A309-EA22 GY- 18 N 216-4725 04 ATCH WORK TOOLS - XR
142-8634
"12V 3.17A"
CONN 3 (18) LH STOP TAIL LAMP
A751-PA8 YL- 16
A752-PA129 BR- 14
(45) POWER STUD (A) A309-EA23 GY- 18 403-EA7 GN- 18 1

W
B+
N 225-7961 04 ATCH WORK TOOLS - ARC
(Dimensions: 39 inches x 24 inches)

142-7503 114-4516
321-H11 BR- 18 C444-PA66 YL- 18 A346-EA16 BU- 18 1

R 216-4704 04 OPT JOYSTICK - RIGHT

"12V 1.42A"
604-H9 OR- 18 E918-PA37 GN- 18 109-EA20 RD- 4
F780-PA35 PK- 18 109-PA38 RD- 8 1

C444-EA9 YL- 18 NOTE A: WIRE PAIRS TO BE TWISTED TOGETHER T 216-4709 03 ATCH MACHINE SECURITY SYSTEM
604-H2 OR- 18 G982-PA40 PK- 18 109-PA53 RD- 8 1

321-H11 BR- 18 G984-PA45 PK- 18 109-PA56 RD- 12 1 1

C444-EA26 YL- 18 AT LEAST ONE TURN PER 25 mm U 221-3876 05 ATCH WIPER / WASHER
1

200-H6 BK- 18 604-H12OR- 18 G985-PA49 PU- 18 C444-EA27 YL- 18 V 221-3877 05 ATCH WIPER / WASHER AUX
(16) LICENSE LAMP 1

617-LJ8 BR- 18 605-H4 YL- 18 L987-PA62 WH- 18 NOTE B: ASSEMBLE TERMINALS TO STUD
(16) BACKUP ALARM 109-WA1 RD-12
190-8962 1

200-LJ7 BK- 18 161-2539 606-H7 GY- 18 PA-C21 M732-PA1 OR- 18 102-PA2 RD- 14 C444-EA30 YL- 18 W 165-4894 02 ATCH WATER PUMP
"12V 0.63A" "12V 0.2A" 617-H3 BR- 18 1003320 M901-PA36 YL- 18 NOTE C: IF ROADING LAMP ATCH HARN IS USED,
(45) AIR FILTER INDICATOR ENG GND STRAP AC 221-3879 03 ATCH AIR CONDITIONING
618-H8 YL- 18 SWITCH(A) A 440-PA72 BR- 18 P983-PA60 GN- 18 109-PA38 RD- 8 L987-EA17 WH- 18
7G-1060 CONN KJ-C2 TO P-C17 (OR PA-C17) AND KJ-C3 TO H-C1
241-3394
B 200-PA4 BK- 18 P987-PA43 GN- 18 109-PA53 RD- 8 M732-EA13 OR- 18 CN 225-7999 04 OPT CAB - NACD ONLY
P991-PA87 PK- 18 109-PA56 RD- 12
"64 mbar; 6 W"
110-PA58 GN- 18 NOTE D: IF REAR AUX HYD ATCH HARN IS USED, FJ 202-2168 02 ATCH AC COMPRESSOR JUMPER
200-PA13 BK- 18 ASSEMBLE ENG GND STRAP CONN RH-C2 TO N-C1 AND RH-C1 TO W-C1 HE 186-3362 00 ATCH HORN JUMPER
200-PA89 BK- 18 109-EA19 RD- 12 FROM ENGINE FLYWHEEL HSG (49) ENGINE GROUND
109-EA20 RD- 4 TO ENG GND STUD ON STUD (A) JA 233-5825 01 ATCH DUAL CONT - LAMP IND
105-PA32 RD- 16 308-PA93 YL- 18 1

109-PW1 RD- 4 109-EA18 RD- 12 BACK SIDE OF FUEL TANK NOTE E: USE REAR LAMP EXTENSION HARNESS
109-PA56 RD- 12 403-PA50 GN- 18 101-EA6 RD- 4 1 1

109-EA21 RD- 4 (INCLUDED IN LOWER FRAME AS.) NOTE B RA-C2 WITH ROADING ATCH REAR LAMPS JC 233-5828 01 ATCH DUAL CONT - SOL IMP PLT 2
105A
WC-C2 117-PA105 YL- 18 405-PA34 GY- 18 TO HIGH FLOW (FL-C5) 1552269
H-C3 1552269 118-PA57 GY- 14 406-PA33 PU- 18 (45) MAIN BREAKER (A) (VOL 1, LOC C-6) RA-C6 203-RA26 BK- 18 F766-RA23 WH- 18 1 COIL AS. JE 233-5826 01 ATCH DUAL CONT - SOL IMP PLT 1
1552272 WC-C1 PA-C11 171-2212 EA-C3 3E3364 203-RA25 BK- 18 2 172-0970 NOTE J: FOR MSS ATCH REMOVE CONN PC-26 (OR PA-C26)
1 WC-1 YL- 16 119-PA3 PK- 18 A346-PA42 BU- 18 OR BOOST FLOW (FW-C8) KJ 216-4727 03 ATCH ROADING LAMP EXTENSION
RJ-C2 RJ-C1 1 606-H7 GY- 18 COIL S-1 3E3376 1552272 123-PA92 WH- 18 C444-PA66 YL- 18 NOTE B 1552269 1 120-RA17 YL- 18 203-RA15 BK- 18 "1.2A NOMINAL 1.8A MAX" AND THEN CONNECT P-C25 (OR PA-C25) TO T-C2}
1552272 3E3376 TAIL 2 WC-2 BK- 16 HARNESS
WH 2 200-H10 BK- 18 WC-1 YL- 16 1 779-PA65 WH- 18 127-PA31 OR- 18 L987-PA62 WH- 18 A309-EA15 GY- 18 1 (33) FUEL SHUTDOWN SOLENOID (A) (VOL 1, LOC C-4) 2 203-RA25 BK- 18 KR 216-4726 05 ATCH ROADING LAMP (RIGHT SIDE) XR
1 606-RJ1 GY- 18 1 RD 3 604-H2 OR- 18 WC-2 BK- 16 K927-PA41 BU- 18 128-PA5 PK- 18 M732-PA1 OR- 18 200-EA24 BK- 18 271-2117 RA-C5
TO REAR DOOR WC-C3 2 2
1552252 NOTE K: JUMPER AS. REQUIRED FOR USE KR 225-7990 02 ATCH ROADING LAMP (RIGHT SIDE) ARC
TO RH STOP
TAIL LAMP
2
3
200-RJ2 BK- 18
604-RJ3 OR- 18
2
3
HARNESS H-C3 STOP
BK 4 618-H8 YL- 18 1552269 WC-3
WC-4
BK- 16
RD- 16
3 K927-PA52 BU- 18
780-PA64 PU- 18
134-PA26 YL- 16
135-PA21 BU- 16
101-EA6 RD- 4 CONN 28 549-RA16 PK- 18
P994-RA2BU- 18 1 WITH HIGH FLOW MACHINES.
LOC B-8 1 WC-4 RD- 16
4
109-WA1 RD-12 LJ 186-0239 01 E ATCH LH REAR LAMP EXTENSION
4 618-RJ4 YL- 18 4
CONN 2 COIL S-2 2 WC-3 BK- 16
CONN 1
144-PA18 GN- 16
306-PA59 GN- 18 EA-C4 (14) ENGINE COOLANT 975-RA6 WH- 18 203-RA15 BK- 18
P997-RA3BR- 18
P996-RA1GN- 18
2
3 NOTE L: CKT P981 FOR TWO-SPEED SOLENOID RA 225-8009 03 OPT JOYSTICK C+ / C-
CONN 2 CONN 2 (17) RH STOP TAIL LAMP
142-7503
(11) QUICK COUPLER SOLENOID(A) 307-PA9 OR- 18
405-PA34 GY- 18 PA-C25 PA-C26 NOTE J 406-EA3 PU- 18
1552269
1
TEMPERATURE SWITCH(A)
231-2999
RA-C7
9X1054 975-RA13 WH- 18
549-RA16 PK- 18
F766-RA24 WH- 18 F766-RA24 WH- 18
4
5 TO RH HANDLE
FOR USE WITH MODELS 236, AND 252. RJ 183-7117 02 ATCH RR DOOR EXT (ITALY ONLY)
"12V 1.42A" 233-7128 PA-C6 1552252 3E5179 30 1
406-PA33 PU- 18 200-EA4 BK- 18 2 120-RA17 YL- 18 H791-RA18 GN- 18 H791-RA18 GN- 18 6 (VOL 1, LOC C-1) WT 225-8012 03 ATCH WORK TOOLS - PLATFORM
"0.92 A MIN, 1.2 A CONT" 1552267 86 5 NOTE P: JUMPER AS. REQUIRED FOR USE
614-PA75 PU- 14 122-PA51 RD- 18 1 102-PA2 RD- 14 1

(7) LOCKOUT RELAY P988-RA12 OR- 18 975-RA14 WH- 18 203-RA15 BK- 18 7

30A T
FOR ROADING ATCH TO STOP LAMP SW A 110-PA102 GN- 18 674-PA29 BU- 18 203-PA116 BK- 18 2 203-PA121 BK- 18 115-1615 85
2 975-RA14 WH- 18 H792-RA10 BR- 18 H792-RA10 BR- 18 8 WITH TWO-SPEED SOLENOID ATCH HARNESS AS - 236, 252
RR DOOR EXT HARN USE 142-8634
12V 3.17A
ATCH HARNESS G-C1
(VOL 2, LOC D-3)
B
C
200-PA6 BK- 18
604-PA100 OR- 18
676-PA30 PU- 18
944-PA81 OR- 18
945-PA77
944-PA81
BR- 18
OR- 18
3
4
(45) ROADING BREAKER (A)
147-1773 EA-C5
87
87a
4
3
F766-RA22 WH- 18
C460-RA21 BU- 18
P994-RA2BU- 18
P996-RA1GN- 18 549-RA16 PK- 18
9
10
NOTE T: TERMINALS BE ASSEMBLED INTO CONNECTOR CALLED OUT
A 216-4702 06 LOWER PLATFORM
1552269
(ITALY ONLY) (ATCH) CONN 5 945-PA77 BR- 18
A346-PA42 BU- 18
308-PA117
403-PA119
YL- 18
GN- 18
5
6
308-PA123 YL- 18
405-EA5 GY- 18 1
(33) ENGINE OIL
PRESSURE SWITCH(A) F766-RA23 WH- 18
P997-RA3BR- 18 11
12 IN GROUP LEVEL DURING MACHINE ASSEMBLY E 216-4721 06 ENGINE
A751-PA8 YL- 16 G798-PA17 PU- 18 7 203-PA124 BK- 18 200-EA25 BK- 18 2 291-1265 F766-RA24 WH- 18 P 258-4199 00 UPPER PLATFORM
VALVE DVTR ARC MTL A752-PA129 BR- 14 A347-PA11 GN- 18 8 308-PA123 YL- 18 HIGH FLOW MACHINES ONLY CONN 33
REAR DOOR (52) VALVE DVTR XR
XRMTL SOLENOID(A) 224-9418
PA-C3
C444-PA66 YL- 18
E918-PA37 GN- 18
203-PA78
306-PA59
BK- 18
GN- 18
9 203-PA124
306-PA122
BK- 18
GN- 18 304-EA11 WH- 12 NOTE B
RA-C1
3E5179
F766-RA22 WH- 18
H791-RA18 GN- 18
NOTE K
JUMPER AS
HARNESS AS - 216, 226, 232, 242, 247, 257
223-8408 1552272
10
EA-C8 549-RA16 PK- 18 RA-C3 133-9931 HIGH FLOW XPS MACHINES ONLY A 309-4039 01 HARNESS AS.-PLATFORM (LOWER)(MTL)
F780-PA35 PK- 18 A346-PA42 BU- 18 11 306-PA122 GN- 18 1 H792-RA10 BR- 18
RD-18 1 RD-18 1 200-PA74 BK- 18 G982-PA40 PK- 18 M732-PA1 OR- 18 12 203-PA121 BK- 18 1
1552272 2 203-RA26 BK- 18 1552267 NOTE K A 309-1951 01 HARNESS AS.-PLATFORM (LOWER)(SSL)
G S
2 2 200-PA79 BK- 18 G984-PA45 PK- 18 A309-EA22 GY- 18 1 TO UPPER PLATF 3 C460-RA21 BU- 18 P984-RA20 YL- 18 C460-RA21 BU- 18 A BK-18
(15) DIODE ASSEMBLY (19) HIGH FLOW SWITCH EA 317-2691 00 ENGINE
RD-18 3 RD-18 3 F905-PA69 YL- 18
F905-PA68 YL- 18
G985-PA49 PU- 18
L987-PA62 WH- 18
CONN 8 MTR BAT
1

101-EA6 RD- 4 110-EA1 GN- 18

200-EA14 BK- 18
2
BLOCK HARNESS A-C6
4
5
975-RA6 WH- 18
P984-RA20 YL- 18
P986-RA7PU- 18 P984-RA20 YL- 18
P986-RA7PU- 18
B
C BK-18 224-0744
4 4 3
(VOl 1, LOC C-2) EG 318-0555 01 COLD START RELAY JUMPER
20 Page,

M732-PA1 OR- 18 101-CG1 RD- 00 A309-EA23 GY- 18 4 172-9200 6 P986-RA7PU- 18 BK-16

CONN 32
1 1

M901-PA36 YL- 18 MOTOR POS NEG 7 P988-RA5OR- 18 P988-RA5OR- 18 RD-16 FW 225-8005 03 OPT HIGH FLOW
P983-PA60 GN- 18 NOTE B 8 P994-RA2BU- 18 RA-C4 BU-16
(10) STARTER(A) 1552269 PA 292-1159 00 UPPER PLATFORM
P987-PA43 GN- 18 9 P996-RA1GN- 18 P988-RA11 OR- 18
163-3361 (11) BATTERY (A) 10 P997-RA3BR- 18 P988-RA12 OR- 18 P988-RA11 OR- 18 1 (19) IMPLEMENT PILOT SOLENOID
CALLOUT FORMAT IF APPLICABLE P991-PA87 PK- 18
153-5656 - 650 CCA 11 H791-RA18 GN- 18 975-RA13 WH- 18 2 195-9700
WIRE AS.
230-6368 - 880 CCA 12 H792-RA10 BR- 18 "0.78A MIN 1.11A CONTINUOUS" PW 225-7982 03 MAIN BRK TO PWR STUD
P994-RA2BU- 18
Callout Number Component CBL-CA1 BK-00
CONN 27 P996-RA1GN- 18 WA 225-8013 01 ATCH LIGHTING BREAKER JUMPER
(52) VALVE GP - CONTROL
84 1
4
12 A-T
16

(Machine Location from Name (15) GLOW PLUGS (A)

E

304-EA11 WH- 12 877-EA10 YL- 12 1

P997-RA3BR- 18 WC 245-1911 02 ATCH QCPLR JUMPER

Component Locations Table) 172-4585
138-1234 Part Number "81.6A MAX 14.4A STEADY-STATE" WC 245-1911 02 ATCH QCPLR JUMPER
WIRE GROUP COLOR DESCRIPTIONS CONNECTION PLATE
257-8390 CABLE AS.
CA 225-7955 03 MACHINE GROUND
GROUND CIRCUIT SYMBOL DESCRIPTION ABBREV COLOR
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
RH POD HARNESS ATCH FOR MODELS 248, 268 CC 142-7513 04 BATTERY POS TO STARTER (BETA MACH)
PLATFORM AND ENGINE CG 225-7954 03 BATTERY POS TO STARTER (ALPHA MACH)
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON CIRCUIT CONNECTED RD RED FOR MODELS 216, 226, 232, 242, 247, 257 AND HIGH FLOW MODELS 226, 242, 257
STARTING CIRCUIT WH WHITE
CIRCUIT NOT CONNECTED
START AID CIRCUIT OR ORANGE
ELECTRICAL CONNECTION TO
MONITOR CIRCUIT MACHINE STRUCTURE
YL YELLOW THIS SCHEMATIC IS FOR THE 216B2, 226B2, 232B2, 236B2 , 242B2, AND 252B2 SKID STEER
MACHINE SECURITY CONTROL CIRCUIT INTERNAL ELECTRICAL CONNECTION
HEATER AND AIR CONDITIONER CIRCUIT TO SURFACE OF COMPONENT PK PINK Do not operate or work on this product unless you have LOADER AND 247B2, 257B2 MULTI-TERRAIN LOADER ELECTRICAL SYSTEM
read and understood the instruction and warnings in the
TURN SIGNAL / WIPER WASHER CIRCUIT CONNECTOR BK BLACK
relevant Operation and Maintenance Manuals and
VOLUME 1 of 2: ENGINE AND PLATFORM
CAT DATA LINK
GY GRAY relevant service literature. Failure to follow the instruc-
IMPLEMENT CONTROL CIRCUIT
H# CIRCUIT GROUPING DESIGNATION
tions or heed the warnings could result in injury or
MEDIA NUMBER: KENR8654-03
PU PURPLE
AUXILIARY HYDRAULIC CONTROL CIRCUIT.
OPERATOR INTERLOCK CONTROL CIRCUIT.
ATCH WIRE, CABLE, COMPONENT
BR BROWN
death. Proper care is your responsibility. SCHEMATIC PART NUMBER: 319-1857, CHANGE: 00, VERSION: -
/ SPLICE Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
OTHER COLOR DESCRIPTIONS GN GREEN
in neutral and with parking brake set.
BLADE, SPADE, RING OR SCREW
HIGHWAYS TERMINAL BU BLUE Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.
 KENR8654-03
June 2022 Harness And Wire Electrical Schematic Symbols
Symbols

Pressure Temperature Level Flow Circuit Breaker

Symbol Symbol Symbol Symbol Symbol

Symbols and Definitions

Component Location - Volume 2 Fuse: A component in an electrical circuit that will open the circuit if too much current flows
Schematic Machine Schematic Machine through it.
Component Component
Location Location Location Location
Action Lamp Group - LH (COSA) D-8 1 Solenoid - Valve Gp RC1 C-1 56 Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
Action Lamp Group - LH (NACD) D-6 1 Solenoid - Valve Gp RC2 C-1 56 circle indicates that the component has screw terminals and a wire can be disconnected from it.
Action Lamp Group - RH (COSA) C-8 2 Switch - Armrest (COSA) B-9 24

3 42 20 43 1 57
Action Lamp Group - RH (NACD)
Beacon And Beacon Socket (COSA)
C-6
C-8
2
36
Switch - Armrest (NACD)
Switch - Auto Leveler (COSA)
B-7
E-7
24
1
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.
36 Beacon And Beacon Socket (NACD) C-6 36 Switch - Auto Leveler (NACD) E-5 1
Bottle - Washer E-4 43 Switch - AUX Hydraulic Mode (COSA) D-7 1 Ground (Wired): This indicates that the component is connected to a grounded wire. The
Coil - Ferrite Asy. (MSS) D-2 21 Switch - AUX Hydraulic Mode (NACD) D-5 1 grounded wire is fastened to the machine.
Coil - MSS Exciter (COSA) C-8 1 Switch - AUX Pressure Release (COSA) E-7 1
56 Coil - MSS Exciter (NACD)
Control - Machine Security System
D-6
E-1
1
21
Switch - AUX Pressure Release (NACD)
Switch - Beacon (COSA)
E-5
C-7
1
2
Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.
21 Diode - Valve Group Remote Control
Flasher (COSA)
C-1
C-9
56
34
Switch - Cold Start (COSA)
Switch - Cold Start (NACD)
D-7
D-5
1
1

216B2, 226B2, 232B2, 236B2 , 242B2,

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
34 Ground - Cab (COSA)
Ground - Cab (NACD)
E-9
E-7
34
34
Switch - Fan On/Off/On (Heater)
Switch - Fan On/Off/On (HVAC)
D-4
C-4
20
20
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

and 252B2 Skid Steer Loader

Hour Meter (COSA) D-8 1 Switch - Front Working Lamp (COSA) B-7 2
Sender: A component that is used with a temperature or pressure gauge. The sender
Hour Meter (NACD) D-6 1 Switch - Front Working Lamp (NACD) B-5 2
measures the temperature or pressure. Its resistance changes to give an indication to
23 Indicator - Fuel Level (COSA) C-8 2 Switch - Hazard (COSA) C-7 2 T
the gauge of the temperature or pressure.

247B2 and 257B2 Multi-Terrain Loader

Indicator - Fuel Level (NACD) C-5 2 Switch - HVAC Refrigerant Pressure C-3 43
Lamp - Dome (COSA) C-8 2 Switch - Hydraulic Lockout (COSA) C-7 2
Lamp - Dome (NACD) C-6 2 Switch - Hydraulic Lockout (Door) E-3 57 Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.

Electrical System
Lamp - Flood - LH (COSA) E-7 1 Switch - Hydraulic Lockout (NACD) C-5 2
It has a coil that makes an electromagnet when current flows through it. The
Lamp - Flood - LH (NACD) E-5 1 Switch - Hydraulic Quick Coupler (COSA) D-7 1
electromagnet can open or close the switch part of the relay.
Lamp - Flood - RH (COSA) B-8 2 Switch - Hydraulic Quick Coupler (NACD) D-5 1
Lamp - Flood - RH (NACD) B-5 2 Switch - Key Start (COSA) D-8 1 Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
Lamp - Head Turn - LH (Atch) E-1 1 Switch - Key Start (NACD) D-6 1 MJH12175-UP coil that makes an electromagnet when current flows through it. The electromagnet
Lamp - Head Turn - RH (Atch) 2 Switch - Mode Off/On (HVAC) C-4 20 can open or close a valve or move a piece of metal that can do work.
E-1 SCH2825-UP
Lamp - Rear Flood - LH (COSA) E-9 3 Switch - Parking Brake (COSA) D-7 1
SLK8300-UP
Lamp - Rear Flood - LH (NACD) E-7 3 Switch - Parking Brake (NACD) D-5 1 Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
Lamp - Rear Flood - RH (COSA) C-9 4 Switch - Rear Working Lamp (COSA) B-7 2
MTL5700-UP activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
Lamp - Rear Flood - RH (NACD) C-7 4 Switch - Rear Working Lamp (NACD) B-5 2 RLL7700-UP that make electromagnet when current flows through them. It also has an internal switch that places
Motor - Condenser Fan 1 & 2 C-3 23 Switch - Roading Lamps (COSA) C-7 2 BXM4775-UP the latch coil circuit open at the time the coil latches.

55 Motor - Dbl Blower (Heater)

Motor - Dbl Blower (HVAC)
D-4
C-4
20
20
Switch - Seat (COSA)
Switch - Seat (NACD)
B-9
B-7
22
22
HEN8070-UP
SCP5410-UP Harness and Wire Symbols
Motor - Front Wiper E-3 27 Switch - Stop Pressure 1 D-3 55
Relay - Compressor HVAC C-4 20 Switch - Stop Pressure 2 D-3 55 Wire, Cable, or Harness Harness Identification Letter(s):
Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
Relay - Condenser Fan C-4 20 Switch - Tool Power (COSA) D-7 1
Harness Identification Letters and
Relay - Key Switch (Heater) D-4 20 Switch - Tool Power (NACD) D-5 1 Harness Connector Serialization Code:
Harness Connector Serialization
The "C" stands for "Connector" and the
4 Relay - Key Switch (HVAC)
Relay - Stop Lamp
C-4
D-2
20
55
Switch - Turn Signal (COSA)
Switch - Wiper / Washer
B-7
E-3
2
27
Codes (see sample).

AG-C4 L-C12
number indicates which connector in the
harness (C1, C2, C3, ...).
Solenoid - HVAC Compressor Clutch C-3 9 Thermostat (HVAC) C-4 20 L-C12
111-7898 3E-5179 3E-5179
Part Number: for Connector Plug 1
Part Number: for Connector Receptacle
24 2
5A
22 9 2 27 Plug Receptacle Component
Pin or Socket Number Fuse (5 Amps) 9X-1123 Part Number

1 Deutsch connector: Typical representation

325-AG135 PK-14
of a Deutsch connector. The plug contains all
36 4 Volume 2 of 2: Cab and Attachments
2 sockets and the receptacle contains all pins.
Harness identification code:
This example indicates wire group 325, Wire Gauge*
wire 135 in harness "AG". Wire Color
1 Sure-Seal connector: Typical representation
of a Sure-Seal connector. The plug and receptacle *Wire gauge is shown in AWG (American Wire Gauge)
3 2 PUBLICATIONS.CAT.COM 2 contain both pins and sockets. but could also be shown in metric denoted with mm

© 2022 Caterpillar. All Rights Reserved. CAT, CATERPILLAR, LET’S DO THE WORK, their respective logos, “Caterpillar Corporate Yellow”, the

34 “Power Edge” and Cat “Modern Hex” trade dress as well as corporate and product identity used herein, are trademarks of Caterpillar and may not
be used without permission.
24
21 1

Connector Location - Volume 2

57 Schematic Machine
Connector Number
Location Location

23 20 CONN 4
CONN 5
E-3, E-2
D-3
13
55
CONN 8 D-2 34
CONN 9 D-9 34

27 CONN 11
CONN 12
D-9, D-7
D-9, D-7
34
34
CONN 20 C-4, D-4 42

22 CONN 24
CONN 34
C-2
E-2, E-7, E-9
13
34
CONN 35 E-5, E-8 1

43 CONN 36 E-2 13

KENR8654-03 VOL 2 of 2
CONN 37 E-4 43
CONN 38 C-3 9
The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near the
component. See the Component Location Chart.

(Dimensions: 39 inches x 24 inches)

56

55 9 42

20 Page,
MACHINE HARNESS CONNECTOR AND COMPONENT LOCATIONS
 NOTE C

200-KJ8 BK- 16 200-KJ1 BK- 16 KJ-C3

200-KJ15 BK- 16 1552264
200-KJ15 BK- 16 1

118-CN47 GY- 14 118-U1 GY- 16 118-U1 GY- 16 321-KJ13 BR- 18 321-KJ13 BR- 18 2

118-C47 GY- 14 C-C17 200-CN71 BK- 18 CN-C17 118-U11 GY- 16 NOTE C 604-KJ14 OR- 18 604-KJ14 OR- 18 3

200-C71 BK- 18 1552269 200-CN73 BK- 16 1552269 118-U7 GY- 16 605-KJ20 YL- 18 4 TO REAR DOOR
(1) LH FLOOD LAMP(COSA) (1) LH FLOOD LAMP(NACD) KJ-C2 605-KJ20 YL- 18 606-KJ16 GY- 18 5 HARNESS H-C1 KR-C3
200-C73 BK- 16 610-C75 OR- 18 1 439-CN34 YL- 18 610-CN75 OR- 18 1 118-U7 GY- 16 (27) WIPER/WASHER 3E3388 1552273
234-4328 234-4328 605-KJ9 YL- 18 605-KJ4 YL- 18 617-KJ17 BR- 18 6 (VOL 1, LOC B-9)
200-C71 BK- 18 2 610-CN75 OR- 18 200-CN71 BK- 18 2 500-U8 BR- 16 SWITCH TURN
439-C78 YL- 18 "12V 4.58A" 614-CN92 PU- 18 "12V 4.58A" 614-U3 PU- 18 138-4883
1 200-KJ8 BK- 16 618-KJ18 YL- 18 7 605-KR1 YL- 18 1 YL-18

610-C75 OR- 18 E917-CN27 WH- 18 IF WATER PUMP / WIPER ATTACHMENT 200-U9 BK- 16 TO UPPER PLATF 2 321-KJ13 BR- 18 606-KJ16 GY- 18 8 200-KR6 BK- 18 2 BK-18
MARKER
IS USED, REMOVE CN-C22A AND HARNESS P-C17 3 604-KJ14 OR- 18 606-KJ10 GY- 18 606-KJ5 GY- 18 617-KR3 BR- 18 3 WH-18

1
8

4
6
614-C92 PU- 18 C-C22 C-C30 105-CN134 RD- 18 CN-C22 CN-C35 CONNECT CN-C22 TO V-C1; STRAP JUMPER V-C1 V-C2 U-C1 (VOL 1, LOC B-9) 4 605-KJ9 YL- 18 CONN 4 4 BU-18

E917-C27 WH- 18 1552273 3E3382 117-CN45 YL- 18 1552273 3E3382 3E3382 1552273 3E3382 OR PA-C17 5 606-KJ10 GY- 18 617-KJ17 BR- 18 5
CN-C22A TO V-C2 FOR SERVICE REPAIR
118-C47 GY- 14 1 117-CN129 YL- 18 118-CN47 GY- 14 1 1 118-V1 GY- 16 118-V1 GY- 16 1 118-U1 GY- 16 200-U2 BK- 16 MOM MOM (VOL 1, LOC B-7) 6 617-KJ11 BR- 18 617-KJ11 BR- 18 617-KJ6 BR- 18 619-KR4 GN- 18 6 RD-18
ROADING
200-C73 BK- 16 2 E917-C79 WH- 18 123-CN54 WH- 18 200-CN73 BK- 16 2 E917-CN28 WH- 18 2 200-V2 BK- 16 200-V6 BK- 16 2 200-U2 BK- 16 U-C3 7 618-KJ12 YL- 18 200-KR5 BK- 18
8 619-KJ19 GN- 18 618-KJ18 YL- 18 KJ-C1 KR-C1 200-KR6 BK- 18
102-C34 RD- 18 105-C134 RD- 18 614-C92 PU- 18 3 IF WATER PUMP / WIPER ATTACHMENT 127-CN56 OR- 18 614-CN92 PU- 18 3 3 614-V3 PU- 18 614-V3 PU- 18 3 614-U3 PU- 18 200-U2 BK- 16 1117898 3E3382 1552273

5
102-C43 RD- 14 102-C82 RD- 18 117-C45 YL- 18 E917-C27 WH- 18 4 E917-C79 WH- 18 IS USED, REMOVE C-C22A AND (3) REAR LH FLOOD LAMP (NACD) 128-CN131 PK- 18 E917-CN27 WH- 18 4 E917-CN28 WH- 18 4 E917-V4 WH- 18 E917-V4 WH- 18 4 E917-U13 WH- 18 618-KJ12 YL- 18 618-KJ7 YL- 18
619-KJ19 GN- 18 200-KJ1 BK- 16 1 200-KR7 BK- 16 200-KR7 BK- 16 (1) HEAD TURN LAMP LH(ATTCH)
C-C15
117-C129 YL- 18 439-C78 YL- 18 5 CONNECT C-C22 TO V-C1; STRAP JUMPER 234-7727
CN-C15
200-CN11 BK- 18 439-CN34 YL- 18 5 5 439-V5 YL- 18 439-V5 YL- 18 5 439-U12 YL- 18 200-U14 BK- 16 200-U14 BK- 16 CONN 4 605-KJ4 YL- 18 2 605-KR1 YL- 18 605-KR1 YL- 18 3E-7584
105-C86 RD- 18 105-C17 RD- 18 123-C54 WH- 18 6 C-C22A TO V-C2 FOR SERVICE REPAIR. "12V 4.58A" 105-CN134 RD- 18 200-CN53 BK- 18 6 6 506-V7 PU- 16 6 506-U5 PU- 16 200-U9 BK- 16
1552269 105-C134 RD- 18 127-C56 OR- 18 1552269 105-CN86 RD- 18 105-CN17 RD- 18 200-CN80 BK- 18 200-U15 BK- 18 501-U4 GN- 16 606-KJ5 GY- 18 3 606-KR2 GY- 18 606-KR2 GY- 18 (RH DIPPED)
617-KJ6 BR- 18 4 617-KR3 BR- 18 617-KR3 BR- 18
1
2
608-C38 GN- 18
200-C57 BK- 18 117-C155 YL- 18 117-C45 YL- 18
128-C131 PK- 18
200-C41 BK- 18
CONN 35 1
2
608-CN38 GN- 18
200-CN57 BK- 18 117-CN45 YL- 18
200-CN84 BK- 18
200-CN88 BK- 18
CONN 35 CONN 35 CONN 37 439-U12 YL- 18
506-U5 PU- 16
(27) WIPER MOTOR (FRONT) 618-KJ7 YL- 18 5 618-KR10 YL- 18 618-KR10 YL- 18
117-C129 YL- 18 200-C53 BK- 18 117-CN155 YL- 18 117-CN129 YL- 18 200-CN90 BK- 18 V-C3 248-2376 619-KJ19 GN- 18 6 619-KR11 GN- 18
(3) REAR LH FLOOD LAMP (COSA) 1237615 "12V 4A" 619-KR11 GN- 18
118-C47 GY- 14 200-C80 BK- 18 118-CN47 GY- 14 201-CN31 BK- 18 500-U8 BR- 16 KR-C2
234-7727
"12V 4.58A"
200-C84 BK- 18 203-CN18 BK- 18 1 U-C2
CONN 36 1552273
122-C49 RD- 18 200-C88 BK- 18 122-CN49 RD- 18 405-CN127 GY- 18 506-V7 PU- 16 TURN
122-C19 RD- 18 122-C48 RD- 18 200-C90 BK- 18 200-CN32 BK- 14 122-CN19 RD- 18 122-CN48 RD- 18 614-CN81 PU- 18 200-V8 BK- 16 1552272 BK-16 619-KR4 GN- 18 606-KR2 GY- 18 1 YL-18
2 GND 619-KR8 GN- 18 200-KR5 BK- 18 2 BK-18
ASSEMBLE 200-C32 BK- 14 201-C31 BK- 18 ASSEMBLE 200-CN33 BK- 14 123-CN55 WH- 18 614-CN83 PU- 18 501-U4 GN- 16 200-U9 BK- 16 1 BK-16 MOTOR MARKER
STRAP CAB GND 200-C33 BK- 14 203-C18 BK- 18 STRAP CAB GND 123-CN1WH- 18 123-CN54 WH- 18 614-CN89 PU- 18 (43) BOTTLE WASHER ASSEMBLY 500-U8 BR- 16 2 GN-16 - + 618-KR10 YL- 18 3 WH-18
T 4 BU-18
FROM BOSS ON 123-C1 WH- 18 123-C54 WH- 18 405-C127 GY- 18 FROM BOSS ON 614-CN91 PU- 18 219-9739 501-U4 GN- 16 3 RD-16
5
UPPER FRAME AS. 123-C55 WH- 18 614-C81 PU- 18 UPPER FRAME AS. 614-CN150 PU- 18 118-U7 GY- 16 4 YL-16
B+ P
614-C83 PU- 18 (1) AUX PRESSURE RELEASE 201-CN31 BK- 18 123-CN132 WH- 18 123-CN6WH- 18 779-CN23 WH- 18 506-U5 PU- 16 619-KR8 GN- 18 6 RD-18
TO CAB GND TO CAB GND ROADING
201-C31 BK- 18 123-C132 WH- 18 123-C6 WH- 18 614-C89 PU- 18 P987-C130 GN- 18 SWITCH (COSA) 123-CN52 WH- 18 780-CN22 PU- 18 P987-CN130 GN- 18
202-C139 BK- 18 123-C52 WH- 18 614-C91 PU- 18 128-C131 PK- 18 223-5941 202-CN139 BK- 18 A751-CN62 YL- 16 128-CN131 PK- 18 614-U3 PU- 18
127-C56 OR- 18 614-C150 PU- 18 STRAP CAB GND 127-CN56 OR- 18 A752-CN63 BR- 14 (1) AUX PRESSURE RELEASE
203-CN125 BK- 16 (2) HEAD TURN LAMP RH(ATTCH)

10

10
MOM

MOM

MOM

MOM
128-C131 PK- 18 779-C23 WH- 18 128-CN131 PK- 18 F780-CN64 PK- 18 SWITCH (NACD) E917-U13 WH- 18

1
8

4
6

4
6
STRAP CAB GND 7G-1060
203-C125 BK- 16 780-C22 PU- 18 (34) CAB GROUND(NACD) F905-CN15 YL- 18 223-5941 3E-7584
7G-1060 (34) CAB GROUND(COSA) (RH DIPPED)
134-C162 YL- 14 A751-C62 YL- 16 NOTE B K927-CN30 BU- 18
NOTE B (57) HYDRAULIC LOCKOUT
134-C35 YL- 14 A752-C63 BR- 14 134-CN159 YL- 14 K927-CN126 BU- 18
REMOVE RECP END CAP C-C26 134-C135 YL- 14 F780-C64 PK- 18 C-C7 CN-C26 L987-CN20 WH- 18 CN-C7 SWITCH(DOOR)
THEN CONNECT 1552272 F905-C15 YL- 18 2285856
REMOVE RECP END CAP
THEN CONNECT
1552272 134-CN35 YL- 14 P983-CN61 GN- 18 2285856 U-C4 229-8757 ROADING LAMP HARNESS AND JUMPER ATCH

9
C-C26 1 F846-C65 PU- 18 135-C136 BU- 16 K927-C126 BU- 18 1 F846-CN65 PU- 18 134-CN135 YL- 14 P987-CN130 GN- 18 1552267
CN-C26
TO MACHINE 2 G848-C66GN- 18 144-C59 GN- 18 K927-C161 BU- 18 105-C134 RD- 18 2 G848-CN66GN- 18 P991-CN147 PK- 18 105-CN134 RD- 18 200-U15 BK- 18 A BK-18
TO MACHINE
SECURITY 3 T902-C68 PK- 18 200-C80 BK- 18 405-C127 GY- 18 (1) TOOL POSISTION SELF 3 T902-CN68 PK- 18 135-CN136 BU- 16 405-CN127 GY- 18 E917-U13 WH- 18 B WH-18
SECURITY
HARNESS T-C3 4 T901-C67 YL- 18 200-C53 BK- 18 L987-C20 WH- 18 F905-C15 YL- 18 LEVELER SWITCH (COSA) 4 T901-CN67 YL- 18 144-CN59 GN- 18 105-CN17 RD- 18 439-U12 YL- 18 C GN-18
HARNESS T-C3
(VOL 2, LOC E-2) 200-C84 BK- 18 P983-C61 GN- 18 614-C81 PU- 18 142-9116 122-CN49 RD- 18 F905-CN15 YL- 18
(VOL 2, LOC E-2)
CONN 34 NOTE A 200-C90 BK- 18 P987-C130 GN- 18
CONN 34
NOTE A 200-CN117 BK- 18 123-CN55 WH- 18 614-CN81 PU- 18 (1) TOOL POSISTION SELF (21) MACHINE SECURITY SYSTEM CONTROL
T-C1 156-6155
WASHER PUMP AND WIPER / WASHER ATCH

10

10
200-C88 BK- 18 P991-C147 PK- 18 200-CN133 BK- 18 200-CN70 BK- 18 LEVELER SWITCH (NACD)

1
8

4
6

4
6
1506766
C-C21 200-C72 BK- 18 200-C77 BK- 18 CN-C21 200-CN120 BK- 18 200-CN77 BK- 18 142-9116
1673692 105-C17 RD- 18 1673692 NOTE M 200-CN32 BK- 14 200-CN109 BK- 18 307-CN13 OR- 18 122-T5 RD- 18 1 BATTERY
1 102-C43 RD- 14 200-C73 BK- 16 122-C49 RD- 18 1 200-CN51 BK- 18 308-CN12 YL- 18 CONN 34 T-C3
3E3376 203-T6 BK- 18 3 GROUND
2 105-C86 RD- 18 200-C70 BK- 18 123-C55 WH- 18 C-C6 2 105-CN86 RD- 18 200-CN96 BK- 18 403-CN2GN- 18 CN-C6
3 117-C155 YL- 18 200-C71 BK- 18 200-C70 BK- 18 2285856 3 117-CN155 YL- 18 200-CN95 BK- 18 404-CN5YL- 18 2285856 TO CAB HARNESS C-C26 1 F846-T1 PU- 18 122-T5 RD- 18

9
4 118-C47 GY- 14 200-C72 BK- 18 200-C95 BK- 18 200-C77 BK- 18 4 118-CN47 GY- 14 200-CN72 BK- 18 200-CN124 BK- 18 405-CN8GY- 18 (VOL 2, LOC E-9) 2 G848-T2 GN- 18 203-T6 BK- 18 A346-T14 BU- 18 5 DRIVER #2 OUTPUT
5 200-C32 BK- 14 200-C51 BK- 18 307-C13 OR- 18 200-C53 BK- 18 5 406-CN3PU- 18 200-CN53 BK- 18 OR CN-C26 3 T902-T21 PK- 18 306-T11 GN- 18
6 200-C98 BK- 18 200-C96 BK- 18 308-C12 YL- 18 117-C45 YL- 18 6 436-CN16 OR- 18 117-CN45 YL- 18 G-C4 (VOL 2, LOC E-7) 4 T901-T20 YL- 18 T901-T4 YL- 18 7 EXCITER COIL SIGNAL LINE
7 122-C19 RD- 18 403-C2 GN- 18 7 122-CN19 RD- 18 674-CN10 BU- 18 9X1054 306-T18 GN- 18
30 NOTE A DRIVER #1 INPUT
8 123-C1 WH- 18 200-C133 BK- 18 404-C5 YL- 18 A752-C63 BR- 14 8 123-CN1WH- 18 676-CN9PU- 18 A752-CN63 BR- 14 HEATER GP 110-G7 GN- 18 1 (55) STOP LAMP RELAY 306-T19 GN- 18 308-T16 YL- 18 9
86 T901-T20 YL- 18
9 127-C56 OR- 18 200-C109 BK- 18 405-C8 GY- 18 614-C150 PU- 18 9 127-CN56 OR- 18 200-CN73 BK- 16 T901-CN67 YL- 18 614-CN150 PU- 18 218-6393 C576-G1BU- 18 5 115-1615
10 128-C131 PK- 18 200-C103 BK- 18 406-C3 PU- 18 (1) POWER TOOLS 10 128-CN131 PK- 18 200-CN53 BK- 18 T902-CN68 PK- 18 (1) POWER TOOLS
BK2
NOTE S CONN 20 200-G5 BK- 18 2
85
T902-T21 PK- 18 308-T9 YL- 18 A347-T12 GN- 18 11 DRIVER #1 OUTPUT
SWITCH (COSA)

10

10
SWITCH (NACD) YL1
134-C162 YL- 14 200-C105 BK- 18 436-C16 OR- 18 200-CN80 BK- 18 110-G4 GN- 18 604-G3 OR- 18

1
134-CN159 YL- 14

1
8

4
6

4
6
11 11 4
142-8633 85 86 TO UPPER G-C1 87 308-T13 YL- 18 13
12 135-C136 BU- 16 200-C111 BK- 18 674-C10 BU- 18 12 135-CN136 BU- 16 200-CN70 BK- 18 142-8633 BK1 1 TO LOWER PLATFORM 3 (21) FERRITE COIL ASSEMBLY (MSS)
TO UPPER PLATFORM PLATFORM P-C21 3E3370 87a 308-T16 YL- 18
13 144-C59 GN- 18 200-C98 BK- 18 200-C117 BK- 18 676-C9 PU- 18 TO UPPER PLATFORM13 144-CN59 GN- 18 200-CN90 BK- 18 87 30
YL1 2 HARNESS A-C8 110-G6 GN- 18 222-3870
HARNESS P-C2 14 307-C13 OR- 18 200-C120 BK- 18 T901-C67 YL- 18 HARNESS P-C2 14 307-CN13 OR- 18 200-CN72 BK- 18 200-CN84 BK- 18 RD3 GN1 GN1 3 (VOL 1, LOC C-9) A 110-G4 GN- 18 110-G7 GN- 18 308-T17 YL- 18
(VOL 1, LOC D-6) T-C5 T-C4
(VOL 1, LOC D-8)
OR PA-C2
15
16
404-C5 YL- 18
405-C87 GY- 18
200-C124
200-C160
BK- 18
BK- 18
T902-C68 PK- 18 C-C5
2285856
(VOL 1, LOC D-8) 15
OR PA-C2 16
404-CN5YL- 18
405-CN87 GY- 18
200-CN88 BK- 18
200-CN77 BK- 18
LH PANEL CN-C5
2285856
HIGH 6
OR2
4 OR PA-C6
(VOL 1, LOC A-7)
B
C
200-G5 BK- 18
604-G3 OR- 18 200-G5 BK- 18 (55) STOP PRESS SWITCH 1
1552269 1552269 403-T10 GN- 18

9
(VOL 1 , LOC C-6) 17 406-C3 PU- 18 (VOL 1, LOC C-6) 17 406-CN3PU- 18 200-CN71 BK- 18 RD3 OFF (20) KEY SWITCH 604-G3 OR- 18 G-C2 1 WH-18 WH-18 1 T901-T4 YL- 18 944-T8 OR- 18 306-T18 GN- 18 18 DRIVER #2 INPUT
5 4 184-1564
18 436-C16 OR- 18 200-C80 BK- 18 18 436-CN16 OR- 18 200-CN80 BK- 18 RELAY (HEATER) C457-G2BU- 18 1552269 2 BK-18 BK-18 2 T902-T3 PK- 18 945-T7 BR- 18 19
19 440-C36 BR- 18 A751-C62 YL- 16 19 440-CN36 BR- 18
HARNESS AS DIODE
266-2928 A751-CN62 YL- 16
LOW
3
YL2
236-5069 CONN 5 C576-G1BU- 18 1 BK-18 A346-T14 BU- 18
20 C444-C25 YL- 18 20 C444-CN25YL- 18 C576-G1BU- 18 C457-G2BU- 18 2 BK-18 NOTE A NOTE A A347-T12 GN- 18
21
22
447-C29 PK- 18
614-C14 PU- 14
LH PANEL K927-C126 BU- 18
21
22
447-CN29 PK- 18
614-CN14 PU- 14 200-CN33 BK- 14 200-CN11 BK- 18 K927-CN126 BU- 18
2
1
GN2 F846-T1 PU- 18
G798-T23 PU- 18
23 674-C10 BU- 18 K927-C161 BU- 18 23 674-CN10 BU- 18 200-CN40 BK- 18 SUPPR ARC K927-CN30 BU- 18 (55) STOP PRESS SWITCH 2 G848-T2 GN- 18 308-T17 YL- 18 24 KEYSWITCH ON POSITION INPUT
HARNESS AS DIODE
24 676-C9 PU- 18 780-C22 PU- 18 24 676-CN9PU- 18 200-CN42 BK- 18 106-8704 780-CN22 PU- 18 L G-C3 184-1564 M732-T15 OR- 18
266-2928 YL2
25 A751-C62 YL- 16 779-C23 WH- 18 25 A751-CN62 YL- 16 200-CN57 BK- 18 BK-18 1 779-CN23 WH- 18 BK5 MOTOR 1552269 NOTE A T901-T4 YL- 18 403-T10 GN- 18 26 ALTERNATOR R TERMINAL INPUT
(1)HYDRAULIC QUICK 7 T-C2
26 A752-C63 BR- 14 200-C57 BK- 18 200-C41 BK- 18 26 A752-CN63 BR- 14 200-CN57 BK- 18 BK-18 2 (1)HYDRAULIC QUICK OR2 H 110-G6 GN- 18 1 BK-18 T902-T3 PK- 18
COUPLER SWITCH (COSA) 3E5179

10

10
MOM

MOM

MOM

MOM
779-C23 WH- 18 200-C33 BK- 14 200-C40 BK- 18 200-CN42 BK- 18 COUPLER SWITCH (NACD) (20) BLOWER MOTOR SWITCH (HEATER) C457-G2BU- 18

1
779-CN23 WH- 18

1
8

4
6

4
6
27 27 2 BK-18
SUPPR ARC 212-6521 1 122-T5 RD- 18 29
28 780-C22 PU- 18 200-C44 BK- 18 28 780-CN22 PU- 18 122-CN49 RD- 18 1

RD-18 212-6521 236-5067 (20) DBL BLOWER

29 F780-C64 PK- 18 200-C42 BK- 18 106-8704 29 F780-CN64 PK- 18 MOTOR (HEATER)
2 203-T6 BK- 18 NOTE A
3 945-T7 BR- 18 306-T19 GN- 18 31 KEYSWITCH CRANK POSITON INPUT
CONN 12 30
31
M901-C7YL- 18
F905-C15 YL- 18 201-C31 BK- 18
BK-18
BK-18
1
2 C-C4 CONN 12 30
31
M901-CN7YL- 18
F905-CN15 YL- 18 200-CN70 BK- 18 1

BK-18 - + CN-C4
231-8125 BK6
STOP LAMP SW ATCH
TO UPPER PLATFORM
HARNESS P-C25
4 944-T8 OR- 18
2285856 2285856 BK5 5 308-T9 YL- 18
(VOL 1, LOC C-8) OR TO

9
122-C49 RD- 18 RD-18 201-CN31 BK- 18 SIG 6 403-T10 GN- 18
UPPER PLATFORM
1

C-C24 202-C139 BK- 18 117-C129 YL- 18 CN-C24 403-CN2GN- 18 GN-18 117-CN129 YL- 18 7 G798-T23 PU- 18
HARNESS PA-C25
1

3E5179 200-C41 BK- 18 3E5179 202-CN139 BK- 18 (1) HOUR METER (NACD) 200-CN11 BK- 18 8 A347-T12 GN- 18
(VOL 1, LOC A-6) 9
1 403-C2 GN- 18 203-C125 BK- 16 203-C18 BK- 18 200-C70 BK- 18 1

BK-18 - + L987-C20 WH- 18 1 403-CN2GN- 18 200-5717

2 E918-C60 GN- 18 203-C74 BK- 18 614-C83 PU- 18 2 E918-CN26 GN- 18 203-CN125 BK- 16 203-CN18 BK- 18 L987-CN20 WH- 18 10 306-T11 GN- 18
3 K927-C30 BU- 18 SIG (1) COLD START 3 K927-CN158 BU- 18 203-CN94 BK- 18 614-CN83 PU- 18 (1) COLD START 11 A346-T14 BU- 18
SWITCH (COSA) SWITCH (NACD)

10

10
P981-C4 PU- 18 307-C13 OR- 18 403-C2 GN- 18 TO UPPER PLATFORM 12 M732-T15 OR- 18 40

1
P981-CN4PU- 18

4
6

4
6
4 GN-18 4
TO UPPER PLATFORM
1

(1) LH(NACD) LAMP GROUP ACTION

MOM

MOM
5 G982-C21PK- 18 308-C12 YL- 18 (1) HOUR METER (COSA) 142-9325 HARNESS P-C8 5 G982-CN21PK- 18 CN-C16 142-9325
HARNESS P-C8 223-6537
(VOL 1, LOC C-8) 6
7
P983-C61 GN- 18
G984-C58PK- 18
403-C2 GN- 18
404-C5 YL- 18
200-5717 (VOL 1, LOC C-8)
OR PA-C8
6
7
P983-CN61 GN- 18
G984-CN58PK- 18
307-CN13 OR- 18
308-CN12 YL- 18 123-CN55 WH- 18
1552252
1 + BATTERY
CONN 8 944-T8 OR- 18 42 CAT DATA LINK +
OR PA-C8
(VOL 1, LOC B-6)
8 G985-C137 PU- 18 (1) LH(COSA) LAMP GROUP ACTION C-C3 (VOL 1, LOC B-6) 8 G985-CN137PU- 18 403-CN2GN- 18 200-CN77 BK- 18 2 GROUND CN-C3
9 L987-C20 WH- 18 405-C8 GY- 18 C-C16 2285856 9 L987-CN20 WH- 18 404-CN5YL- 18 406-CN3PU- 18 3 COOLANT HIGH TEMP 2285856 945-T7 BR- 18 45 CAT DATA LINK -

9
1552252 223-6537
10 P987-C130 GN- 18 405-C87 GY- 18 405-C127 GY- 18 10 P987-CN130 GN- 18 674-CN10 BU- 18 4 PARKING BRAKE
47
11 P991-C147 PK- 18 123-C55 WH- 18 1 + BATTERY 200-C84 BK- 18 11 P991-CN147 PK- 18 405-CN8GY- 18 404-CN5YL- 18 5 HYD OIL HIGH TEMP 200-CN84 BK- 18 NOTE A
12 308-C12 YL- 18 406-C3 PU- 18 200-C77 BK- 18 2 GROUND 127-C56 OR- 18 12 308-CN12 YL- 18 405-CN87 GY- 18 405-CN127GY- 18 436-CN16 OR- 18 6 DIRTY HYD OIL FILTER 127-CN56 OR- 18
436-C16 OR- 18 406-C3 PU- 18 3 COOLANT HIGH TEMP 676-CN9PU- 18 7 ARM REST / SEAT POS
CONN 11 674-C10 BU- 18 4 PARKING BRAKE F780-C64 PK- 18 CONN 11 406-CN3PU- 18 8 EXT ALARM F780-CN64 PK- 18
404-C5 YL- 18
436-C16 OR- 18
5
6
HYD OIL HIGH TEMP
DIRTY HYD OIL FILTER
614-C89 PU- 18
(1) PARKING BRAKE
436-CN16 OR- 18
405-CN8GY- 18
9
10
EXT ALARM
LOW OIL PRESSURE
614-CN89 PU- 18
(1) PARKING BRAKE HEATER GP ATCH M732-T15 OR- 18 52 DRIVER #2 GROUND RETURN
EXCITER COIL RETURN LINE

10

10
C-C25 439-C46 YL- 18 676-C9 PU- 18 SWITCH (COSA) 439-CN34 YL- 18 SWITCH (NACD) T902-T3 PK- 18 53
1

1
8

4
6

4
6
7 ARM REST / SEAT POS 11 NOT USED

MOM

MOM
TO UPPER PLATFORM 1552272 439-C78 YL- 18 8 EXT ALARM 142-9320 439-CN24 YL- 18 12 NOT USED 142-9320
HARNESS P-C10 1 439-C151 YL- 18 9 EXT ALARM 439-CN151 YL- 18
(VOL 1, LOC C-8) 2 605-C11 YL- 18 405-C8 GY- 18 10 LOW OIL PRESSURE
OR PA-C10 3 606-C28 GY- 18 440-C36 BR- 18 11 NOT USED C-C2 440-CN36 BR- 18 CN-C2
(VOL 1, LOC B-6) 4 619-C26 GN- 16 447-C29 PK- 18 12 NOT USED 2285856 447-CN29 PK- 18 2285856 G798-T23 PU- 18 58 DRIVER #1 GROUND RETURN
7

9
537-C24 GN- 18 CN-C18
1552272 R F846-T1 PU- 18 60 RED LED SIGNAL LINE
CONN 9 603-C69 PK- 18
C-C18
R
200-C88 BK- 18
201-C31 BK- 18
608-CN37 GN- 18
608-CN38 GN- 18 608-CN39 GN- 16 308-CN12 YL- 18 1 YL-16
C OFF
200-CN88 BK- 18
201-CN31 BK- 18
605-C11 YL- 18 1552272 123-C54 WH- 18 2 PU-16 123-CN54 WH- 18 G848-T2 GN- 18 62 GREEN LED SIGNAL LINE
S ON
606-C28 GY- 18 308-C12 YL- 18 1 YL-16 P991-C147 PK- 18 (1) AUX HYDRAULIC MODE 610-CN75 OR- 18 307-CN13 OR- 18 3 OR-16 ST P991-CN147 PK- 18
C OFF B 308-T13 YL- 18 64 DRIVER 2 ENABLE INPUT
2 PU-16 ON
P983-C61 GN- 18 SWITCH(COSA) (HIGH FLOW) 610-CN100 OR- 18 105-CN17 RD- 18 4 BR-16 P983-CN61 GN- 18
S
608-C37 GN- 18 307-C13 OR- 18 3 OR-16 ST 614-C91 PU- 18 223-5942 610-CN99 OR- 16 (1) KEY START SWITCH (NACD) 614-CN91 PU- 18
B (1) AUX HYDRAULIC MODE 66
C-C20 608-C38 GN- 18 608-C39 GN- 16 105-C17 RD- 18 4 BR-16 142-8858 SWITCH(NACD) (HIGH FLOW)
10

10
1918332
1

1
8

4
6

4
6
(1) KEY START SWITCH (COSA) 223-5942 68
142-8858
1 610-C75 OR- 18 614-CN81 PU- 18
70
- GROUND 2 200-C44 BK- 18 610-C100 OR- 18 614-CN150 PU- 18
3 610-C99 OR- 16 +- C-C1 614-CN83 PU- 18 NOTE A CN-C19 (1) MSS EXCITER COIL (NADC) +- CN-C1 AIR CONDITIONER GP
LAMP OUT 4 537-C24 GN- 18 NOTE A C-C19 (1) MSS EXCITER COIL (COSA) 2285856 614-CN89 PU- 18 1552269 205-8257 2285856 218-6405
7

9
5 1552269 205-8257 614-CN91 PU- 18 T902-CN68 PK- 18 1 BK
+ BATTERY 6 102-C34 RD- 18 614-C83 PU- 18
614-C89 PU- 18
T902-C68 PK- 18
T901-C67 YL- 18
1
2
BK
BK
200-C90 BK- 18
203-C18 BK- 18
614-CN92 PU- 18
614-CN41 PU- 18
T901-CN67 YL- 18 2 BK 200-CN90 BK- 18
203-CN18 BK- 18 BK3
MACHINE SECURITY SYSTEM ATCH
(34) FLASHER ASSEMBLY (COSA) BK2
614-C91 PU- 18
242-9000 614-C81 PU- 18
YL1 NOTE R
CONN 20
614-C92 PU- 18 614-CN76PU- 18 (20) BLOWER MOTOR
614-C150 PU- 18 614-CN128 PU- 18 85 86 BK1 1 RH-C3
SWITCH (HVAC) RD2 TO LOWER PLATFORM
614-C76 PU- 18 614-CN123 PU- 18 236-5067 YL1 2 3E3364
(2) BEACON 30 HARNESS A-C8
603-C69 PK- 18 SWITCH (COSA) 614-CN14PU- 14 614-CN119 PU- 18 RD3 GN1 GN1 3 M906-RH14BU- 16 1
614-C104 PU- 18 614-CN118 PU- 18
87
4 (VOL 1, LOC D-6) 200-RH12 BK- 16 2
142-9327 HIGH 6
614-C106 PU- 18 614-CN157 PU- 18 OR2
C-C27 (2) RH(COSA) LAMP GROUP ACTION CN-C27 (2) RH(NACD) LAMP GROUP ACTION (56) VALVE GP RC2 SOLENOID
10

614-C157 PU- 18 674-CN10 BU- 18 RD3 (20) KEY SWITCH 200-RH7BK- 16 200-RH1BK- 16
1
8

4
6

200 BK-18 OFF

1552252 249-2910 1552252 249-2910 5 4 215-3272
614-C104 PU- 18 676-CN9PU- 18 LOW YL2 RELAY (HVAC)
614-C101 PU- 16 123-C6 WH- 18 1 + BATTERY 779-CN23 WH- 18 123-CN6WH- 18 1 + BATTERY GN2 236-5069
614-C114 PU- 16 200-C51 BK- 18
NOTE N 200-CN51 BK- 18
3
200-RH12 BK- 16 RH-C4
2 GROUND 2 3 780-CN22 PU- 18 2 GROUND
2 (20) DBL BLOWER 200-RH12 BK- 16 1552269
M901-C7YL- 18 3 INTERLOCK OVERRIDE C-C14 A751-CN62 YL- 16 M901-CN7YL- 18 3 INTERLOCK OVERRIDE
1
GN3
MOTOR (HVAC) 200-RH6BK- 16 200-RH13 BK- 16
G848-C66GN- 18 4 MSS GREEN 2285856 WIRE AS.-BEACON A752-CN63 BR- 14 G848-CN66GN- 18 4 MSS GREEN 200-RH20 BK- 14 200-RH13 BK- 16 M907-RH16GY- 16 1
231-8125
7

614-C14 PU- 14 439-C151 YL- 18 5 IMPLEMENT LOCKOUT 165-0312 C444-CN25YL- 18 439-CN24 YL- 18 5 IMPLEMENT LOCKOUT M906-RH14BU- 16 200-RH13 BK- 16 2
614-C158 PU- 18 440-C36 BR- 18 6 AIR FILTER IND 200-C103 BK- 18 E918-CN26 GN- 18 440-CN36 BR- 18 6 AIR FILTER IND L
7 YL2
614-C110 PU- 18 P981-C4 PU- 18 7 TWO SPEED 144-C59 GN- 18 P981-CN4PU- 18 7 TWO SPEED BK5 MOTOR NOTE D A571-RH19 PU- 14 M906-RH15BU- 16 (56) VALVE GP RC1 SOLENOID
C-C32 614-C123 PU- 18 F846-C65 PU- 18 8 MSS RED 614-C128 PU- 18 CN-C32 E917-CN27 WH- 18 F846-CN65 PU- 18 8 MSS RED BK6 OR2 H A752-RH2BR- 16 M907-RH16GY- 16 212-3350
1552269 614-C113 PU- 16 9 G982-C21PK- 18 1552269 F780-CN64 PK- 18 9 AC-C40 (43) HVAC PRESSURE SWITCH RH-C2 C460-RH18BU- 14 M907-RH17GY- 16
1 608-C37 GN- 18 614-C119 PU- 18 C444-C25 YL- 18 10 ALTERNATOR FAIL E918-C60 GN- 18 1 608-CN37 GN- 18 F846-CN65 PU- 18 C444-CN25YL- 18 10 ALTERNATOR FAIL BK6 200-AC8 BK- 10 1684999 236-6923 1552264 M733-RH5PK- 14
2 200-C42 BK- 18 614-C118 PU- 18 11 439-C46 YL- 18 (2) HYDRAULIC LOCKOUT SWITCH(COSA) 2 200-CN42 BK- 18 F905-CN15 YL- 18 11 200-AC4 BK- 14 567-AC9 WH -18 A 3 1 200-RH7BK- 16
614-C128 PU- 18 12 614-C157 PU- 18 226-5901 G848-CN66GN- 18 12 BK5 200-AC5 BK- 14 200-AC6 BK-18 B 2 TO WKTL HARN N-C1 2 A752-RH2BR- 16 M906-RH14BU- 16 RH-C5
(4) REAR RH FLOOD LAMP (COSA) (4) REAR RH FLOOD LAMP (NACD) G982-CN21PK- 18 BK4 200-AC6 BK- 18 1 (VOL 1, LOC E-5) 3 M906-RH9BU- 16 M906-RH8BU- 16 M906-RH15BU- 16 1552269
10

234-7727 619-C26 GN- 16 234-7727 G984-CN58PK- 18 200-AC7 BK- 18

CONN 38 4 M907-RH11GY- 16 M907-RH17GY- 16 1 (56) DIODE
1
8

4
6

"12V 4.58A" 674-C10 BU- 18 "12V 4.58A" G985-CN137PU- 18 B A 5 200-RH20 BK- 14 M906-RH15BU- 16 2 106-8704
RD4 BU
676-C9 PU- 18 (2) DOME LAMP(NACD) 6 M733-RH5PK- 14 M906-RH9BU- 16 M906-RH3BU- 16
(2) DOME LAMP(COSA) BK/WH1 AC-C5 FJ-C1 FJ-C2
779-C23 WH- 18 122-C48 RD- 18 1

MOM MOM K927-CN158 BU- 18 122-CN48 RD- 18 1

084-4277 85 86 513-AC10 OR- 18 7 C460-RH18BU- 14

780-C22 PU- 18 200-C96 BK- 18 1

084-4277 C-C13 200-CN96 BK- 18 1 T 1552269 3E3364 1552269 8 A571-RH19 PU- 14 M907-RH11GY- 16 M907-RH4GY- 16
"12V 0.83A" 200-RH20 BK- 14 NOTE D RH-C1
0.83A 2285856 K927-CN30 BU- 18 (20) THERMOSTAT (HVAC) 87 30 514-AC11 PU- 14 513-AC10 OR- 18 1 447-FJ1 PK-18 1 RD-18
M907-RH10GY- 16
7

A751-C62 YL- 16 K927-CN126 BU- 18 119-9631

WH RD2
514-AC1 PU- 14 200-AC7 BK- 18 2 200-FJ2 BK-18 2 RD-18 CONN 24 200-RH1BK- 16 3E3388
A752-C63 BR- 14 200-C109 BK- 18 L987-CN20 WH- 18 514-AC2 PU- 14 M907-RH16GY- 16 A571-RH19 PU- 14 200-RH1BK- 16 1
E917-C27 WH- 18 M901-CN7YL- 18 (9) HVAC COMPRESSOR M907-RH17GY- 16 A752-RH2BR- 16 A752-RH2BR- 16 2
(20) COMPRESSOR CLUTCH SOLENOID C460-RH18BU- 14 TO WATER PUMP HARN W-C1
C444-C25 YL- 18 203-C74 BK- 18 P981-CN4PU- 18 567-AC9 WH- 18 M906-RH3BU- 16 3
123-C52 WH- 18 (2) FUEL LEVEL INDICATOR 200-C133 BK- 18 P983-CN61 GN- 18 236-5069 RELAY (HVAC) 231-6287 M733-RH5PK- 14 M907-RH4GY- 16 4 (VOL 1, LOC E-5)
E917-C27 WH- 18 ASSEMBLY(COSA) 614-C106 PU- 18 536-C108 WH
- 18 P987-CN130 GN- 18 M906-RH3BU- 16 200-RH20 BK- 14 5
(2) FUEL LEVEL INDICATOR BK/WH2 M907-RH4GY- 16
170-6305 P991-CN147 PK- 18 AC-C2 M733-RH5PK- 14 6
IGN ASSEMBLY(NACD) BK3
10

E918-C60 GN- 18 (2) HAZARD SWITCH (COSA) T901-CN67 YL- 18 123-CN52 WH- 18 C460-RH18BU- 14 7
1
8

4
6

IGN 1552269
447-C29 PK- 18 142-9331 T902-CN68 PK- 18 170-6305 85 86 A571-RH19 PU- 14 8
SEND BK/WH2 514-AC1 PU- 14 1 (23) CONDENSER FAN
F846-C65 PU- 18 447-CN29 PK- 18 SEND 614-CN123PU- 18 RD5 ASSEMBLY MOTOR
200-AC4 BK- 14 2 MOTOR
F780-C64 PK- 18 2
87 30 CONN 25
F905-C15 YL- 18
G848-C66GN- 18
200-C124 BK- 18
GRD
C-C12
2285856 1
GRD
3
GN2 RD1 218-6250
"12V 16A" REAR AUXILIARY HYDRAULIC ATCH
7

200-CN124 BK- 18
G982-C21PK- 18
G984-C58PK- 18 614-C123 PU- 18 200-C105 BK- 18 614-CN123 PU- 18 (20) CONDENSER FAN RELAY
G985-C137 PU- 18 537-C24 GN- 18 537-C107 GN- 18 7 236-5069
BK4
RD5 AC-C3
K927-C30 BU- 18 C-C23 619-C26 GN- 16 CN-C23 RD4 1552269
K927-C30 BU- 18 1237615 (36) BEACON (COSA) 614-C101 PU- 16 1237615 (36) BEACON (NACD) 8 AC-C1 (23) CONDENSER FAN
NOTE R 1552267 514-AC2 PU- 14 1
K927-C126 BU- 18 128-6985 614-C110 PU- 18 128-6985 ASSEMBLY MOTOR
1
"12V 4.7A MAX" (2) ROADING LAMP 1
"12V 4.7A MAX" (20) MODE SWITCH OFF/ON (HVAC) 200-AC5 BK- 14 2 MOTOR
K927-C161 BU- 18 603-C69 PK- 18 144-CN59 GN- 18 OR1 A 514-AC11 PU- 14 218-6250
ON - OFF
10

200-C40 BK- 18 SWITCH (COSA) 200-CN40 BK- 18 WH 513-AC10 OR- 18 "12V 16A" IDENT PART NO. CHG NOTE ATCH DESCRIPTION
1
8

4
6

B
2 2 202-2284
L987-C20 WH- 18 142-9329 BK/WH1 C 567-AC9 WH- 18
(36) BEACON SOCKET (COSA) (36) BEACON SOCKET (NACD) HARNESS AS - COMMON
M901-C7YL- 18 9R-7941 9R-7941
C-C11
C 216-4752 07 OPT CAB - EAME ONLY
P981-C4 PU- 18 2285856 200-AC8 BK- 10 1

TO LOWER PLATF GND F 272-1626 03 ATCH DEMAND FAN

7

P983-C61 GN- 18 (VOL 1 LOC C-2)

P987-C130 GN- 18 200-C160 BK- 18 G 216-4711 04 ATCH STOP LAMP SW
P991-C147 PK- 18 102-C82 RD- 18
H 216-4703 04 REAR DOOR
T901-C67 YL- 18
RH PANEL 102-C112 RD- 16
RH PANEL 614-CN128 PU- 18
G982-CN21PK- 18
HVAC [ATCH] J 233-5824 01 ATCH DUAL CONT - BKUP ALM
T902-C68 PK- 18 E918-CN26 GN- 18
537-C121 GN- 18 439-CN151 YL- 18 (2) HYDRAULIC LOCKOUT SWITCH(NACD) N 216-4725 04 ATCH WORK TOOLS - XR
536-C108 WH- 18 614-CN157 PU- 18 226-5901
122-C48 RD- 18 536-C122 WH- 18 J-C2 SNSR HYD TEMP. F-C3 N 225-7961 04 ATCH WORK TOOLS - ARC
1552269 130-9811 1552269

10
123-C6 WH- 18 R 216-4704 04 OPT JOYSTICK - RIGHT

1
8

4
6
123-C52 WH- 18 122-CN48 RD- 18 200-J3 BK- 18 1 SIGNAL 1 R732-F5 BR- 18
200-C40 BK- 18 537-C107 GN- 18 123-CN6WH- 18 321-J2 BR- 18 2 GROUND 2 J764-F6 BR- 18 T 216-4709 03 ATCH MACHINE SECURITY SYSTEM
200-C51 BK- 18 614-C113 PU- 16 605-C116 YL- 18 123-CN52 WH- 18 MOM MOM J-C1
200-C96 BK- 18 144-CN59 GN- 18 CN-C13 3E3364 U 221-3876 05 ATCH WIPER / WASHER
DEFAULT 101-9161 070-0333 107-5630
10

200-C124 BK- 18 200-CN40 BK- 18 2285856 V 221-3877 05 ATCH WIPER / WASHER AUX
1

120-J1 YL- 18
8

4
6

(2) TURN SIGNAL 1

9
439-C151 YL- 18 SWITCH (COSA) 200-CN51 BK- 18 2 321-J2 BR- 18
440-C36 BR- 18 226-5900 200-CN96 BK- 18 200-CN109 BK- 18 MINIMUM FAN SPEED 1870 1345 1345 1870 SNSR COOL. TEMP F-C4 W 165-4894 02 ATCH WATER PUMP
447-C29 PK- 18 200-CN124 BK- 18 E917-CN27 WH- 18 J-C3 238-0112 2304011 F-C11
603-C69 PK- 18 C-C10 439-CN24 YL- 18 203-CN94 BK- 18 1552269 MAXIMUM FAN SPEED 3400 2800 2450 3400 SIGNAL 1 R995-F7 BU- 18 1552269 AC 221-3879 03 ATCH AIR CONDITIONING
614-C123 PU- 18 2285856 440-CN36 BR- 18 200-CN133 BK- 18 120-J1 YL- 18 1 GROUND 2 J764-F8 BR- 18 180-F26 GN- 18 1 CN 225-7999 04 OPT CAB - NACD ONLY
7

C444-C25 YL- 18 (24) ARMREST SWITCH (NACD) 447-CN29 PK- 18 200-J3 BK- 18 2 OVERRIDE SPEED 2450 2015 1765 2450 961-F27 BR- 18 2
F846-C65 PU- 18 200-C111 BK- 18 606-C115 GY- 18 162-0223 614-CN123 PU- 18 FJ 202-2168 02 ATCH AC COMPRESSOR JUMPER
G848-C66GN- 18 606-C28 GY- 18 605-C116 YL- 18 C444-CN25YL- 18 CONNECT TO OVRD CAL
C-C28 M901-C7YL- 18 605-C11 YL- 18 CN-C28 F846-CN65 PU- 18 110-F22 GN- 18 JPR CONNECTOR HE 186-3362 00 ATCH HORN JUMPER
3E3376 P981-C4 PU- 18 606-C115 GY- 18 3E3376 G848-CN66GN- 18 JA-C1 JA-C2 CONN TO APPLICABLE CODE PLUG: F-C5 110-F25 GN- 18
3E3364 1552269 1552272
JA 233-5825 01 ATCH DUAL CONT - LAMP IND
BK 1 202-C139 BK- 18 610-C99 OR- 16 BK 1 202-CN139 BK- 18 M901-CN7YL- 18 101-9161 [MODELS 248, 268, 287] 110-F16 GN- 18
RD 2 G984-C58PK- 18 614-C114 PU- 16 RD 2 G984-CN58PK- 18 P981-CN4PU- 18 610-CN99 OR- 16 (2) FRONT WORKING LAMP SWITCH(NACD) 1 975-JA1 WH- 18 975-JA1 WH- 18 1 070-0333 [MODELS 246, 262, 277, 287] 1 M904-F1OR- 18 110-F21 GN- 18 JC 233-5828 01 ATCH DUAL CONT - SOL IMP PLT 2
OR 3 G983-C138 GN- 18 102-C82 RD- 18 614-C118 PU- 18 OR 3 G983-CN138GN- 18 614-CN41 PU- 18 142-9328 2 H416-JA2 GN- 18 H416-JA2 GN- 18 2 107-5630 [MODELS 226, 242, 247, 257] 2 M905-F2WH- 18 110-F21 GN- 18
(24) ARMREST SWITCH (COSA) 4 134-C35 YL- 14 (2) FRONT WORKING 4 614-CN118 PU- 18 [NOTE: MODELS 216 AND 232 DO NOT 3 X734-F3 GY- 18 180-F26 GN- 18 JE 233-5826 01 ATCH DUAL CONT - SOL IMP PLT 1
162-0223
10

10
134-C135 YL- 14 LAMP SWITCH(COSA) 134-CN35 YL- 14
1

1
200-F4 BK- 18
8

4
6

4
6
JE-C1 JE-C2
USE DEMAND FAN ATCH] 4 KJ 216-4727 03 ATCH ROADING LAMP EXTENSION
135-C136 BU- 16 142-9328 WIRE AS. SEAT SW 134-CN135 YL- 14
C-C29 144-C59 GN- 18 154-3985 CN-C29 135-CN136 BU- 16 3E3364 1552269 KR 216-4726 05 ATCH ROADING LAMP (RIGHT SIDE) XR
1552269 200-C103 BK- 18 (22) SEAT SWITCH (NACD) 1552269 200-CN109 BK- 18 1 P988-JE1 OR- 18 P988-JE1 OR- 18 1
(22) SEAT SWITCH (COSA) SNSR SP DEMAND FAN KR 225-7990 02 ATCH ROADING LAMP (RIGHT SIDE) ARC
200-C105 BK- 18 C-C9 CN-C9 F-C6
KENR8654-03 VOL 2 of 2

154-3986 YL 1 G983-C138 GN- 18 154-3986 YL 1 G983-CN138GN- 18 200-CN117 BK- 18 2 975-JE2 WH- 18 975-JE2 WH- 18 2 200-F4 BK- 18
YL 2 G985-C137 PU- 18 200-C109 BK- 18 2285856 YL 2 G985-CN137PU- 18 200-CN120 BK- 18 2285856 278-8713 1552267 200-F17 BK- 18
153-1260 SUSPENDED SEAT 153-1260 SUSPENDED SEAT LJ 186-0239 01 E ATCH LH REAR LAMP EXTENSION
7

9
200-C111 BK- 18 200-CN133 BK- 18 POSITIVE YL/GN A 110-F21 GN- 18 200-F18 BK- 18
200-C117 BK- 18 200-C117 BK- 18 203-CN94 BK- 18 200-CN117 BK- 18 OUTPUT BR B Y952-F10 YL- 18 200-F19 BK- 18 RA 225-8009 03 OPT JOYSTICK C+ / C-
200-C120 BK- 18 134-C135 YL- 14 439-CN151 YL- 18 134-CN135 YL- 14 JC-C1 JC-C2 GROUND BU C 200-F9 BK- 18 200-F24 BK- 18
200-C133 BK- 18 134-C35 YL- 14 608-CN39 GN- 16 134-CN35 YL- 14 3E3364 1552269 200-F9 BK- 18 RJ 183-7117 02 ATCH RR DOOR EXT (ITALY ONLY)
200-C160 BK- 18 1 P988-JC1 OR- 18 P988-JC1 OR- 18 1
WT 225-8012 03 ATCH WORK TOOLS - PLATFORM
203-C74 BK- 18 610-CN99 OR- 16 2 975-JC2 WH- 18 975-JC2 WH- 18 2
439-C46 YL- 18 608-C39 GN- 16 614-CN41 PU- 18 608-CN39 GN- 16 (2) REAR WORKING LAMP SWITCH (NACD) SOL DEMAND FAN HARNESS AS - 236, 252
537-C24 GN- 18 614-C119 PU- 18 614-CN118 PU- 18 614-CN119 PU- 18 261-6727
142-9326 1.6 A MAX A 216-4702 06 LOWER PLATFORM
(Dimensions: 39 inches x 24 inches)

603-C69 PK- 18 614-CN119 PU- 18 F-C7 F-C1 CONT ELEC DEMAND FAN
1552269 2538110 GRAY 270-1629
10

10
605-C11 YL- 18 (2) REAR WORKING LAMP SWITCH (COSA) 614-CN128 PU- 18
1

1
604-F23 OR- 18
8

4
6

4
6
JF-C1 JF-C2 E 216-4721 06 ENGINE
606-C28 GY- 18 142-9326 614-CN157 PU- 18 1 H746-F11 YL- 18 180-F26 GN- 18 1 +5V REF
608-C39 GN- 16 E917-CN27 WH- 18 3E3370 1552267 2 H747-F12 BR- 18 961-F27 BR- 18 2 OVRD SW IP P 258-4199 00 UPPER PLATFORM
610-C99 OR- 16 E918-CN26 GN- 18 A C460-JF1 BU- 18 C460-JF1 BU- 18 A 961-F27 BR- 18 N979-F13 GN- 18 3 ANLG GND
614-C114 PU- 16 C-C8 G982-CN21PK- 18 CN-C8 B P984-JF2 YL- 18 P984-JF2 YL- 18 B H747-F12 BR- 18 4 SOL A- HARNESS AS - 216, 226, 232, 242, 247, 257
614-C101 PU- 16 2285856 2285856 C P986-JF3 PU- 18 P986-JF3 PU- 18 C H746-F11 YL- 18 5 NOT USED
A 309-4039 01 HARNESS AS.-PLATFORM (LOWER)(MTL)
7

9
614-C104 PU- 18 F-C8 H747-F12 BR- 18 200-F18 BK- 18 6 BAT. -
614-C106 PU- 18 200-C120 BK- 18 200-CN120 BK- 18 1552267 110-F16 GN- 18 7 BAT. + A 309-1951 01 HARNESS AS.-PLATFORM (LOWER)(SSL)
614-C110 PU- 18 135-C136 BU- 16 135-CN136 BU- 16 CONN TO TXD A N960-F14 OR- 18 8 NOT USED
614-C113 PU- 16 RS-232 RXD B N957-F15 PK- 18 H746-F11 YL- 18 9 SOL A+ EA 317-2691 00 ENGINE
614-C118 PU- 18 CONNECTOR SIG GND C N979-F13 GN- 18 J764-F6 BR- 18 N957-F15 PK- 18 10 RS-232 RCV
EG 318-0555 01 COLD START RELAY JUMPER
614-C119 PU- 18 J764-F8 BR- 18 N960-F14 OR- 18 11 RS-232 XMT
614-C128 PU- 18 J764-F20 BR- 18 12 RS-232 GND FW 225-8005 03 OPT HIGH FLOW
614-C157 PU- 18
619-C26 GN- 16 F-C2 PA 292-1159 00 UPPER PLATFORM
E917-C27 WH- 18 CONN TO P-C21 F-C9 M904-F1OR- 18 2538111
3E3370 WIRE AS.
E918-C60 GN- 18 PLATF HARN M905-F2WH- 18 R732-F5 BR- 18 1 TEMP SNSR 1 [HYD]
G982-C21PK- 18 CN-C33 (VOL 1, LOC C-9) A 110-F22 GN- 18 R995-F7 BU- 18 2 TEMP SNSR 2 [ENG COOL.] PW 225-7982 03 MAIN BRK TO PWR STUD
C-C33
1552269 610-CN100 OR- 18 610-CN100 OR- 18
1552269
1
(2) RH FLOOD LAMP(NACD) DUAL CONT [ATCH] OR PA-C6
PLATF HARN
B
C
200-F17 BK- 18
604-F23 OR- 18
N957-F15 PK- 18
N960-F14 OR- 18 J764-F20 BR- 18
3
4
NOT USED
TEMP SNSR GND WA 225-8013 01 ATCH LIGHTING BREAKER JUMPER
610-C100 OR- 18 610-C100 OR- 18 1 (2) RH FLOOD LAMP(COSA) 200-CN95 BK- 18 200-CN95 BK- 18 2 234-4328 N979-F13 GN- 18 200-F19 BK- 18 5 GND
234-4328 "12V 4.58A" (VOL 1, LOC A-7) WC 245-1911 02 ATCH QCPLR JUMPER
200-C95 BK- 18 200-C95 BK- 18 2 6 NOT USED
"12V 4.58A" 202-CN139 BK- 18 R732-F5 BR- 18 M904-F1OR- 18 7 LOC CODE IP, BIT 0 WC 245-1911 02 ATCH QCPLR JUMPER
202-C139 BK- 18 G985-CN137PU- 18 R995-F7 BU- 18 M905-F2WH- 18 8 LOC CODE IP, BIT 1
G984-C58PK- 18 G984-CN58PK- 18 X734-F3 GY- 18 9 LOC CODE IP, BIT 2 CABLE AS.
G985-C137 PU- 18 F-C10 X734-F3 GY- 18 Y952-F10 YL- 18 10 FAN SP FDBK SIG
1552267 11 NOT USED
CA 225-7955 03 MACHINE GROUND
CONN TO G-C1 A 110-F25 GN- 18 Y952-F10 YL- 18 12 NOT USED CC 142-7513 04 BATTERY POS TO STARTER (BETA MACH)
EAME CAB NACD CAB STOP LAMP SW HARN
(VOL 2, LOC D-3)
B
C
200-F24 BK- 18
604-F23 OR- 18
BLACK
CG 225-7954 03 BATTERY POS TO STARTER (ALPHA MACH)

DEMAND FAN [ATCH]

NOTE A: WIRE PAIRS TO BE TWISTED TOGETHER
AT LEAST ONE TURN PER 25 mm

NOTE B: ASSEMBLE TERMINALS TO STUD

NOTE C: IF ROADING LAMP ATCH HARN IS USED,
CONN KJ-C2 TO P-C17 (OR PA-C17) AND KJ-C3 TO H-C1
20 Page,

CALLOUT FORMAT IF APPLICABLE NOTE D: IF REAR AUX HYD ATCH HARN IS USED,

NOTE M: CKT 102 FOR USE WITH EAME MACHINES ONLY

Callout Number
WIRE GROUP COLOR DESCRIPTIONS (Machine Location from (52) VALVE GP - CONTROL
Component
Name Do not operate or work on this product unless you have NOTE N: REMOVE JUMPER WHEN USING BEACON SWITCH
Component Locations Table)
GROUND CIRCUIT 138-1234 Part Number read and understood the instruction and warnings in the
relevant Operation and Maintenance Manuals and NOTE R: HARNESS SUPPLIED WITH AIR CONDITIONING UNIT
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
SYMBOL DESCRIPTION relevant service literature. Failure to follow the instruc- NOTE S: HARNESS SUPPLIED WITH HEATER UNIT
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON ABBREV COLOR
tions or heed the warnings could result in injury or
STARTING CIRCUIT
CIRCUIT CONNECTED RD RED death. Proper care is your responsibility.
START AID CIRCUIT
WH WHITE
TRANSMISSION / ENGINE PUMP CONTROL CIRCUIT CIRCUIT NOT CONNECTED
MONITOR CIRCUIT ELECTRICAL CONNECTION TO
OR ORANGE
MACHINE SECURITY CONTROL CIRCUIT MACHINE STRUCTURE
YL YELLOW
HEATER AND AIR CONDITIONER CIRCUIT INTERNAL ELECTRICAL CONNECTION

TURN SIGNAL / WIPER WASHER CIRCUIT

TO SURFACE OF COMPONENT PK PINK
THIS SCHEMATIC IS FOR THE 216B2, 226B2, 232B2, 236B2 , 242B2, AND 252B2 SKID STEER
CAT DATA LINK CONNECTOR BK BLACK

IMPLEMENT / VALVE / TOOL CONTROL CIRCUIT

LOADER AND 247B2, 257B2 MULTI-TERRAIN LOADER ELECTRICAL SYSTEM
H# GY GRAY
ETHERNET
CIRCUIT GROUPING DESIGNATION
PU PURPLE
VOLUME 2 of 2: CAB AND ATTACHMENTS
ATCH WIRE, CABLE, COMPONENT
OTHER COLOR DESCRIPTIONS BR BROWN MEDIA NUMBER: KENR8654-03
HIGHWAYS / SPLICE
GN GREEN SCHEMATIC PART NUMBER: 319-1857, CHANGE: 00, VERSION: -
BLADE, SPADE, RING OR SCREW
TERMINAL BU BLUE Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.