WWW.JEEPSEA.CO.
IL
COELMO’S GEN SETS
DM series
COMPARISON DM 350 GENSET WITH COMPETITION ( Power, main sizes and weight )
main sizes mm
Weight
Power kW Builder Model engine base
Kg
Length Width Height
3,5 COELMO marine DM 350 Faryman 18 W 615 445 525 105
PMS 4500
3,8 Fischer Panda Faryman 18 W 520 370 520 117
SCB
Yanmar 1
3,0 MASE IS 3,5 590 406 515 96
cylinder
3,5 VOLPI Paguro 4000 Faryman 18 W 550 320 520 83
COMPARISON DM 600 GENSET WITH COMPETITION ( Power, main sizes and weight )
main sizes mm
Weight
Power kW Builder Model engine base
Kg
Length Width Height
NANNI N2.10 (Kubota Z
6,0 COELMO marine DM 600 630 465 525 128
482)
5,1 Fischer Panda PMS 6000 ND Kubota Z 482 595 440 600 164
5,7 MASE GS 061 Kubota Z 482 650 468 555 165
5,0 Mastervolt Whisper 6 Mitsubishi L2E 660 495 550 178
5,0 VOLPI Paguro 6000 Lombardini LDW 502 660 460 620 130
DM600
Main features
• Aluminium sound proof canopy with
polyester marine paint
• Sound proof material with PVC plate
• Large access possibility on the 5 sides
• Water cooling system:
- engine cooled by heat exchanger
sea water / fresh water
- alternator cooled by sea water
• Hydraulic and electric connections located
on the same side
• Electronic remote control and protection
system
• Easy installation on board
• Reduced dimensions
• Low noise level
• Large accessories range
10/12/2007 4
DM600
10/12/2007 5
DM600
• Holes for Siphon breaker
piping on both sides
10/12/2007 6
DM600
Hydraulic links
• Fuel inlet & outlet
• Sea water inlet
• Exhaust outlet
Electric links
• Battery cables inlet
• Power cable outlet
• Signal cable
All on the same side
10/12/2007 7
DM600
• Large access trough
every 5 sides to allow the
Genset checking and
maintenance
• Possibility to dismantle
the canopy in every part
to extract the Genset and
to put it in open version in
the case of extraordinary
maintenance
10/12/2007 8
DM600
Complete local control
board with:
• Genset circuit breaker
• Local/remote selector
10/12/2007 9
DM600
• Possibility of fast
replacing of diodes
trough this door
10/12/2007 10
DM600
• Ordinary maintenance
concentrated on the
front side :
> sea water pump,
> oil filter
> alternator belt
10/12/2007 11
DM600
• Fuel feeding and
return and sea water
inlet piping for a fast
and easy installation
10/12/2007 12
DM600
• Genset circuit breaker
• Local/remote selector
10/12/2007 13
EOS Generator Advanced Controller
• Backlight display 128x64 pixels
• Control panel 96 x 96 mm to
install on board with possibility
to interface it with pre-existing
systems (SCADA or similar)
10/12/2007 14
EOS Generator Advanced Controller
ALARMS MEASURES
Low oil pressure Amp,
High water temperature Volt
High exhaust temperature Hz
Alternator battery charger failure Vcc
Fault start Time counter
Mechanical failure Maintenance remaining hours
High frequency generator Water temperature (optional)
Maintenance deadline Oil pressure (optional)
Generator overload
• The display allows to visualize Low battery voltage
alarm messages as reported in
Low alternator voltage
the table. Each of these alarms
will be visualized and could be High alternator voltage
set to provide only signal,
Low frequency generator
engine stop, or start siren relay
Other than the alarms are
checkable also the principal
measures.
10/12/2007 15
DM600 wiring diagram
Wiring diagram 1
10/12/2007 16
DM600 wiring diagram
Wiring diagram 2
10/12/2007 17
DM350
Main features
• Aluminium sound proof canopy with
polyester marine paint
• Sound proof material with PVC plate
• Large access possibility on the 5 sides
• Water cooling system:
> engine cooled by heat exchanger
sea water / fresh water
> alternator cooled by sea water
• Hydraulic and electric connections
located on the same side
• Electronic remote control and protection
system
• Easy installation on board
• Reduced dimensions
• Low noise level
• Large accessories range
10/12/2007 18
DM350
10/12/2007 19
DM350
Hydraulic links
• Fuel inlet & outlet
• Sea water inlet
• Exhaust outlet
Electric links
• Battery cables inlet
• Power cable outlet
• Signal cable
All on the same side
10/12/2007 20
DM350
• Large access trough
every 5 sides to allow the
Genset checking and
maintenance
• Possibility to dismantle
the canopy in every part
to extract the Gen set and
to put it in open version in
the case of extraordinary
maintenance
10/12/2007 21
DM350
Complete local control
board with:
• Genset circuit breaker
• Local/remote selector
• High exhaust
temperature switch
10/12/2007 22
DM350
• The DM350 cooling system
works using exclusively sea
water as cold fluid.
• This system has allowed to
reduce the overall
dimensions and the weight,
in addition to the noise level
reduction.
• Ordinary maintenance
concentrated on the front
side:
- sea water pump
- fuel filter
18/02/2008 23
DM350
Wiring diagram 1
10/12/2007 24
DM350
Wiring diagram 2
10/12/2007 25
