SERVICE MANUAL

Commercial Brand:

Product Line: TWISTER

Code: 112042095

Description: AMPL ADS TWISTER 2X95W

F2-190

VERSION DESCRIPTION FROM S.N. DATE APPROVED

AT001020
0.0 ISSUED 2004/01/07 GIACOMONI
AS19026000

1
 INDEX

INDEX:

1 - SERVICE MANUAL COD: 112042095 VERSION 0.0

a - Characteristic Rev. 0 3
b - Bias Regualtion Procedure Rev. 0 4
c - Part List Rev. 0 5
d - Component Side Layout Rev. 0 6
e - Electrical Scheme Rev. 0 10

SERVICE MANUAL COD: 112042095 VERSION 0.0 2

 a - Characteristic Rev. 0

Quiescent consumption @ 12.6 Volt / 14.4 Volt: 380 mA / 450 mA (without Bias regutation)
Bias regulation @ 14.4 Volt 100 mA (per channel)
Idle consumption @ 12.6 Volt / 14.4 Volt: 570 mA / 650 mA (including 200 mA of Bias )
Thermal protection condition consumption @ 14.4 Volt: 560 mA (including fan consumption)
Secondary voltages (Amp. / Driver / Pre.) @ 12.6 Volt: ±27.1 V / ±6.8 V / ±13.6 V
Secondary voltages (Amp. / Driver / Pre.) @ 14.4 Volt: ±31.1 V / ±6.8 V / ±13.6 V
Battery ground vs secondary ground decopuling: 56 Ohm / 22nF (double diode protection)
Body ground vs battery ground decopuling: 100 Ohm / 22nF
DC to DC conversion frequency: 40 Khz
Input impedance @ 1 KHz (STEREO input): > 11 KOhm
Input capacitance @ 1 KHz (STEREO input): 220 pF
Input impedance @ 1 KHz (MONO input): > 5.5 KOhm
Input capacitance @ 1 KHz (STEREO input): 440 pF
Input ground decopuling: 58 Ohm
Filter slope - Filter “Q”: 12 dB/oct - 0.71
Thermal cutoff: 90 °C (± 6 %)
Overload cutoff @ 14.4Volt (85°C Tcase): 1 Ohm / 2 Ohm (Stereo / Bridged)

Power data acquired @: 14,4 Volt, t = 25°C, 0,3%THD, ±5% tolerance, load: pure resistive. (If not differently specified).

SERVICE MANUAL COD: 112042095 VERSION 0.0 3

 b - Bias Regualtion Procedure Rev. 0

The procedure must be effected without any input signal and any load!

The PCB must be mounted on heatsink!

1. With the amplifier without any connection rotate anticlockwise each trimmer to the end point.

2. Connect the power supply to the amplifier. The input voltage must be 14,4V. You must have a voltmeter and
amperometer to input supply.

3. Switch on the amplifier using the remote input.

4. Wait about 20 sec then read the value of idle current using the amperometer. The standard value is 450 mA.

5. Rotate clockwise the trimmers, one trimmer at time, to increase the iddle current of 100 mA each trimmer..
This procedure must be effected carefully, a fast rotation shall cause an amplifier instability causing a faulty.

6. At the end of the procedure the idle current must be 650 mA.

SERVICE MANUAL COD: 112042095 VERSION 0.0 4

 c - Part List Rev. 0
IC'S
Code Ref.No. Nomenclature Selection Power/Case Description Volt M.Factory

837340140 U1 SG3525 AP SO16 PWM Controller IC ST

837143005 U2 BA15532 F SOP8 Dual Low Noise Operational Amplifier Rohm
837143005 U3 BA15532 F SOP8 Dual Low Noise Operational Amplifier Rohm
837150159 U4 TL074 CD SO14 Quad Low Noise Operational Amplifier ST
837140111 U5 LM339 AD SO14 Quad Voltage Comparator ST

TRANSISTORS AND FETS

Code Ref.No. Nomenclature Selection Power/Case Description Volt M.Factory

836510921 Q1 IRF5210 TO220 P Channel Mosfet Rds(on)=0.06 100V IR

836510920 Q2 IRF3710 TO220 N Channel Mosfet Rds(on)=0.025 100V IR
836510921 Q3 IRF5210 TO220 P Channel Mosfet Rds(on)=0.06 100V IR
836510920 Q4 IRF3710 TO220 N Channel Mosfet Rds(on)=0.025 100V IR
836512705 Q5 HUF75333P3 TO220 N Channel Mosfet Rds(on)=0.016 55V Fairchild
836512705 Q6 HUF75333P3 TO220 N Channel Mosfet Rds(on)=0.016 55V Fairchild
836130453 Q7 BC850 C SOT23 NPN General Purpose Transistor 45V Philips
836130453 Q8 BC850 C SOT23 NPN General Purpose Transistor 45V Philips
836130454 Q9 BC860 C SOT23 PNP General Purpose Transistor 45V Philips
836130453 Q10 BC850 C SOT23 NPN General Purpose Transistor 45V Philips
836130453 Q11 BC850 C SOT23 NPN General Purpose Transistor 45V Philips
836130454 Q12 BC860 C SOT23 PNP General Purpose Transistor 45V Philips
836130454 Q13 BC860 C SOT23 PNP General Purpose Transistor 45V Philips
836130453 Q14 BC850 C SOT23 NPN General Purpose Transistor 45V Philips
836130453 Q15 BC850 C SOT23 NPN General Purpose Transistor 45V Philips
836130454 Q16 BC860 C SOT23 PNP General Purpose Transistor 45V Philips
836130454 Q17 BC860 C SOT23 PNP General Purpose Transistor 45V Philips
836132959 Q18 BCP53 SOT223 PNP Medium Power Transistor 80V Siemens
836120202 Q19 BC337 25 TO92 NPN General Purpose Transistor 45V Motorola
836120201 Q20 BC327 25 TO92 PNP General Purpose Transistor 45V Motorola
836120202 Q21 BC337 25 TO92 NPN General Purpose Transistor 45V Motorola
836120201 Q22 BC327 25 TO92 PNP General Purpose Transistor 45V Motorola
836130251 Q23 BC846 B SOT23 NPN General Purpose Transistor 65V Motorola
836130251 Q24 BC846 B SOT23 NPN General Purpose Transistor 65V Motorola
836130453 Q25 BC850 C SOT23 NPN General Purpose Transistor 45V Philips
836130454 Q26 BC860 C SOT23 PNP General Purpose Transistor 45V Philips
836130454 Q27 BC860 C SOT23 PNP General Purpose Transistor 45V Philips
836130454 Q28 BC860 C SOT23 PNP General Purpose Transistor 45V Philips
836130454 Q29 BC860 C SOT23 PNP General Purpose Transistor 45V Philips
836130453 Q30 BC850 C SOT23 NPN General Purpose Transistor 45V Philips
836130453 Q31 BC850 C SOT23 NPN General Purpose Transistor 45V Philips
836130453 Q32 BC850 C SOT23 NPN General Purpose Transistor 45V Philips

DIODES
Code Ref.No. Nomenclature Selection Power/Case Description Volt M.Factory

835342755 D1 FEP16DT D TO220 16A Super Fast Dual Rectifier 200V Fairchild
835342755 D2 FEP16DT D TO220 16A Super Fast Dual Rectifier 200V Fairchild
835130450 D3 LL4148 SOD80C 200mA Ultra Fast Diode 75V Philips
835130450 D4 LL4148 SOD80C 200mA Ultra Fast Diode 75V Philips
835130450 D5 LL4148 SOD80C 200mA Ultra Fast Diode 75V Philips
835130450 D6 LL4148 SOD80C 200mA Ultra Fast Diode 75V Philips
835130450 D7 LL4148 SOD80C 200mA Ultra Fast Diode 75V Philips
835130450 D8 LL4148 SOD80C 200mA Ultra Fast Diode 75V Philips
835130450 D9 LL4148 SOD80C 200mA Ultra Fast Diode 75V Philips
835321101 D10 1N4937 DO41 1A Fast Rectifier 600V TSC
835321101 D11 1N4937 DO41 1A Fast Rectifier 600V TSC
835221110 D12 1N5402 DO201 3A Standard Rectifier 200V TSC
807170438 D13 15R 5% 2W-Small Metal Oxide Film Resistor
807170438 D14 15R 5% 2W-Small Metal Oxide Film Resistor
835133160 DD1 BAV99 SOT23 200mA Ultra Fast Diode Array 80V Infineon
835133160 DD2 BAV99 SOT23 200mA Ultra Fast Diode Array 80V Infineon
835133160 DD3 BAV99 SOT23 200mA Ultra Fast Diode Array 80V Infineon
835133160 DD4 BAV99 SOT23 200mA Ultra Fast Diode Array 80V Infineon
835133160 DD5 BAV99 SOT23 200mA Ultra Fast Diode Array 80V Infineon
835133160 DD6 BAV99 SOT23 200mA Ultra Fast Diode Array 80V Infineon
835430455 DZ1 BZV55-C6V8 400mW SOD80C Voltage Regulator Diode 6V8 Philips
835430455 DZ2 BZV55-C6V8 400mW SOD80C Voltage Regulator Diode 6V8 Philips
835430453 DZ3 BZV55-C4V7 400mW SOD80C Voltage Regulator Diode 4V7 Philips
835430455 DZ4 BZV55-C6V8 400mW SOD80C Voltage Regulator Diode 6V8 Philips
835430455 DZ5 BZV55-C6V8 400mW SOD80C Voltage Regulator Diode 6V8 Philips

RESISTORS
Code Ref.No. Nomenclature Selection Power/Case Description Volt M.Factory

803613325 R1 7K87 1% 0805-1/8W Chip Resistor

803613585 R2 14K 1% 0805-1/8W Chip Resistor
803613435 R3 10K 1% 0805-1/8W Chip Resistor
803612728 R4 2K2 5% 0805-1/8W Chip Resistor
803614495 R5 100K 1% 0805-1/8W Chip Resistor
803614495 R6 100K 1% 0805-1/8W Chip Resistor

SERVICE MANUAL COD: 112042095 VERSION 0.0 5

 c - Part List Rev. 0

Code Ref.No. Nomenclature Selection Power/Case Description Volt M.Factory

803613175 R7 5K62 1% 0805-1/8W Chip Resistor

803611585 R8 182R 1% 0805-1/8W Chip Resistor
803613435 R9 10K 1% 0805-1/8W Chip Resistor
803611585 R10 182R 1% 0805-1/8W Chip Resistor
803613435 R11 10K 1% 0805-1/8W Chip Resistor
803611048 R12 56R 5% 0805-1/8W Chip Resistor
803610258 R13 10R 5% 0805-1/8W Chip Resistor
803611675 R14 221R 1% 0805-1/8W Chip Resistor
803611675 R15 221R 1% 0805-1/8W Chip Resistor
803614855 R16 221K 1% 0805-1/8W Chip Resistor
803613435 R17 10K 1% 0805-1/8W Chip Resistor
803611048 R18 56R 5% 0805-1/8W Chip Resistor
803610258 R19 10R 5% 0805-1/8W Chip Resistor
803611675 R20 221R 1% 0805-1/8W Chip Resistor
803611048 R21 56R 5% 0805-1/8W Chip Resistor
803610258 R22 10R 5% 0805-1/8W Chip Resistor
803611675 R23 221R 1% 0805-1/8W Chip Resistor
803611675 R24 221R 1% 0805-1/8W Chip Resistor
803614855 R25 221K 1% 0805-1/8W Chip Resistor
803613435 R26 10K 1% 0805-1/8W Chip Resistor
803613435 R27 10K 1% 0805-1/8W Chip Resistor
803611048 R28 56R 5% 0805-1/8W Chip Resistor
803610258 R29 10R 5% 0805-1/8W Chip Resistor
803611675 R30 221R 1% 0805-1/8W Chip Resistor
803611048 R31 56R 5% 0805-1/8W Chip Resistor
803614495 R32 100K 1% 0805-1/8W Chip Resistor
803613435 R33 10K 1% 0805-1/8W Chip Resistor
803614495 R34 100K 1% 0805-1/8W Chip Resistor
803614325 R35 68K1 1% 0805-1/8W Chip Resistor
803614325 R36 68K1 1% 0805-1/8W Chip Resistor
803613295 R37 7K32 1% 0805-1/8W Chip Resistor
805761318 R38 100R 5% 2010-1/2W Chip Resistor
805761318 R39 100R 5% 2010-1/2W Chip Resistor
803611815 R40 301R 1% 0805-1/8W Chip Resistor
806170178 R41 2R2 5% 1W-Small Metal Oxide Film Resistor
803611815 R42 301R 1% 0805-1/8W Chip Resistor
806170178 R43 2R2 5% 1W-Small Metal Oxide Film Resistor
803611675 R44 221R 1% 0805-1/8W Chip Resistor
804662558 R45 1K5 5% 1206-1/4W Chip Resistor
N.C. R46 N.C. N.C. 0805-1/8W Chip Resistor
803613435 R47 10K 1% 0805-1/8W Chip Resistor
803612728 R48 2K2 5% 0805-1/8W Chip Resistor
803613435 R49 10K 1% 0805-1/8W Chip Resistor
803612378 R50 1K 5% 0805-1/8W Chip Resistor
804662558 R51 1K5 5% 1206-1/4W Chip Resistor
N.C. R52 N.C. N.C. 0805-1/8W Chip Resistor
803612728 R53 2K2 5% 0805-1/8W Chip Resistor
803613435 R54 10K 1% 0805-1/8W Chip Resistor
803612378 R55 1K 5% 0805-1/8W Chip Resistor
808270008 R56 0R05 5% 3W-Small Wire Wound Resistor Royal Ohm
808270008 R57 0R05 5% 3W-Small Wire Wound Resistor Royal Ohm
803614325 R58 68K1 1% 0805-1/8W Chip Resistor
803611048 R59 56R 5% 0805-1/8W Chip Resistor
803613435 R60 10K 1% 0805-1/8W Chip Resistor
803611048 R61 56R 5% 0805-1/8W Chip Resistor
803614325 R62 68K1 1% 0805-1/8W Chip Resistor
803611048 R63 56R 5% 0805-1/8W Chip Resistor
803613435 R64 10K 1% 0805-1/8W Chip Resistor
803611048 R65 56R 5% 0805-1/8W Chip Resistor
804662558 R66 1K5 5% 1206-1/4W Chip Resistor
803612028 R67 470R 5% 0805-1/8W Chip Resistor
803612028 R68 470R 5% 0805-1/8W Chip Resistor
803613258 R69 6K8 5% 0805-1/8W Chip Resistor
803613355 R70 8K25 1% 0805-1/8W Chip Resistor
803614495 R71 100K 1% 0805-1/8W Chip Resistor
803613355 R72 8K25 1% 0805-1/8W Chip Resistor
803613258 R73 6K8 5% 0805-1/8W Chip Resistor
803612558 R74 1K5 5% 0805-1/8W Chip Resistor
803616618 R75 10M 5% 0805-1/8W Chip Resistor
803613258 R76 6K8 5% 0805-1/8W Chip Resistor
803612198 R77 680R 5% 0805-1/8W Chip Resistor
805760438 R78 15R 5% 2010-1/2W Chip Resistor
803616618 R79 10M 5% 0805-1/8W Chip Resistor
803613435 R80 10K 1% 0805-1/8W Chip Resistor
803613195 R81 5K9 1% 0805-1/8W Chip Resistor
803613195 R82 5K9 1% 0805-1/8W Chip Resistor
803613195 R83 5K9 1% 0805-1/8W Chip Resistor
803613195 R84 5K9 1% 0805-1/8W Chip Resistor
803613435 R85 10K 1% 0805-1/8W Chip Resistor
803616618 R86 10M 5% 0805-1/8W Chip Resistor
803612795 R87 2K55 1% 0805-1/8W Chip Resistor

SERVICE MANUAL COD: 112042095 VERSION 0.0 6

 c - Part List Rev. 0

Code Ref.No. Nomenclature Selection Power/Case Description Volt M.Factory

803613698 R88 18K 5% 0805-1/8W Chip Resistor

803611048 R89 56R 5% 0805-1/8W Chip Resistor
803614765 R90 182K 1% 0805-1/8W Chip Resistor
803613698 R91 18K 5% 0805-1/8W Chip Resistor
805762378 R92 1K 5% 2010-1/2W Chip Resistor
805762378 R93 1K 5% 2010-1/2W Chip Resistor
803613745 R94 20K 1% 0805-1/8W Chip Resistor
803611675 R95 221R 1% 0805-1/8W Chip Resistor
803612965 R96 3K65 1% 0805-1/8W Chip Resistor
803612965 R97 3K65 1% 0805-1/8W Chip Resistor
803611675 R98 221R 1% 0805-1/8W Chip Resistor
803613745 R99 20K 1% 0805-1/8W Chip Resistor
803614325 R100 68K1 1% 0805-1/8W Chip Resistor
803614765 R101 182K 1% 0805-1/8W Chip Resistor
803616618 R102 10M 5% 0805-1/8W Chip Resistor
803616618 R103 10M 5% 0805-1/8W Chip Resistor
803615558 R104 1M 5% 0805-1/8W Chip Resistor
803613095 R105 4K75 1% 0805-1/8W Chip Resistor
803613585 R106 14K 1% 0805-1/8W Chip Resistor
803615288 R107 560K 5% 0805-1/8W Chip Resistor
803613258 R108 6K8 5% 0805-1/8W Chip Resistor
803613258 R109 6K8 5% 0805-1/8W Chip Resistor
803613258 R110 6K8 5% 0805-1/8W Chip Resistor
803611048 R111 56R 5% 0805-1/8W Chip Resistor
803612558 R112 1K5 5% 0805-1/8W Chip Resistor
803614765 R113 182K 1% 0805-1/8W Chip Resistor
805760438 R114 15R 5% 2010-1/2W Chip Resistor
803613645 R115 16K2 1% 0805-1/8W Chip Resistor
803613645 R116 16K2 1% 0805-1/8W Chip Resistor
805761318 R117 100R 5% 2010-1/2W Chip Resistor
803612375 R118 1K 1% 0805-1/8W Chip Resistor
803612295 R119 825R 1% 0805-1/8W Chip Resistor
803612375 R120 1K 1% 0805-1/8W Chip Resistor
803612295 R121 825R 1% 0805-1/8W Chip Resistor
805760218 R122 4R7 5% 2010-1/2W Chip Resistor
805761938 R123 390R 5% 2010-1/2W Chip Resistor
805761938 R124 390R 5% 2010-1/2W Chip Resistor
803616618 R125 10M 5% 0805-1/8W Chip Resistor
803616618 R126 10M 5% 0805-1/8W Chip Resistor
805762558 R127 1K5 5% 2010-1/2W Chip Resistor
803612198 R128 680R 5% 0805-1/8W Chip Resistor
803612558 R129 1K5 5% 0805-1/8W Chip Resistor
803614148 R130 47K 5% 0805-1/8W Chip Resistor
803614148 R131 47K 5% 0805-1/8W Chip Resistor
803613645 R132 16K2 1% 0805-1/8W Chip Resistor
803613645 R133 16K2 1% 0805-1/8W Chip Resistor
805762558 R134 1K5 5% 2010-1/2W Chip Resistor

POTENTIOMETERS
Code Ref.No. Nomenclature Selection Power/Case Description Volt M.Factory

818026505 POT1-A POT-100K ±5% PGB (Audio) 10 mm Vertical Mounting Trimmer COD:CA9MH2.5 ACP
818026505 POT1-B POT-100K ±5% PGB (Audio) 10 mm Vertical Mounting Trimmer COD:CA9MH2.5 ACP
818026505 POT1-C POT-100K ±5% PGB (Audio) 10 mm Vertical Mounting Trimmer COD:CA9MH2.5 ACP
818026505 POT1-D POT-100K ±5% PGB (Audio) 10 mm Vertical Mounting Trimmer COD:CA9MH2.5 ACP
818026385 POT2-A POT-20K ±5% PGB (Audio) 10 mm Vertical Mounting Trimmer COD:CA9MH2.5 ACP
818026385 POT2-B POT-20K ±5% PGB (Audio) 10 mm Vertical Mounting Trimmer COD:CA9MH2.5 ACP
818001409 TRM1 TRM-22K 20% 6 mm Snap In Horizontal Mounting Trimmer COD:CA6V5 ACP
818001409 TRM2 TRM-22K 20% 6 mm Snap In Horizontal Mounting Trimmer COD:CA6V5 ACP

CAPACITORS
Code Ref.No. Nomenclature Selection Power/Case Description Volt M.Factory

823436561 C1 100n X7R 1206 Ceramic Chip Capacitor 50V AVX

823436561 C2 100n X7R 1206 Ceramic Chip Capacitor 50V AVX
823136525 C3 100p NP0 1206 Ceramic Chip Capacitor 50V AVX
823436551 C4 15n X7R 1206 Ceramic Chip Capacitor 50V AVX
823136509 C5 4p7 NP0 1206 Ceramic Chip Capacitor 50V AVX
823136525 C6 100p NP0 1206 Ceramic Chip Capacitor 50V AVX
823436551 C7 15n X7R 1206 Ceramic Chip Capacitor 50V AVX
823136509 C8 4p7 NP0 1206 Ceramic Chip Capacitor 50V AVX
824672241 C9 220n 5% Step 5 mm Polyester Capacitor 63V TPC
824672241 C10 220n 5% Step 5 mm Polyester Capacitor 63V TPC
823436561 C11 100n X7R 1206 Ceramic Chip Capacitor 50V AVX
823436561 C12 100n X7R 1206 Ceramic Chip Capacitor 50V AVX
823136507 C13 3p3 NP0 1206 Ceramic Chip Capacitor 50V AVX
823136517 C14 22p NP0 1206 Ceramic Chip Capacitor 50V AVX
823136507 C15 3p3 NP0 1206 Ceramic Chip Capacitor 50V AVX
824673237 C16 100n 5% Step 5 mm Polyester Capacitor 100V TPC
824673213 C17 1n 5% Step 5 mm Polyester Capacitor 100V TPC
823436561 C18 100n X7R 1206 Ceramic Chip Capacitor 50V AVX

SERVICE MANUAL COD: 112042095 VERSION 0.0 7

 c - Part List Rev. 0

Code Ref.No. Nomenclature Selection Power/Case Description Volt M.Factory

833053229 C19 22u 85° D5 mm Chip Type Electrolytic Capacitor 16V NIC
824673213 C20 1n 5% Step 5 mm Polyester Capacitor 100V TPC
824673217 C21 2n2 5% Step 5 mm Polyester Capacitor 100V TPC
833056113 C22 1u 85° D4 mm Chip Type Electrolytic Capacitor 50V NIC
833056113 C23 1u 85° D4 mm Chip Type Electrolytic Capacitor 50V NIC
N.C. C24 N.C. N.C. 1206 Ceramic Chip Capacitor N.C.
N.C. C25 N.C. N.C. 1206 Ceramic Chip Capacitor N.C.
823136517 C26 22p NP0 1206 Ceramic Chip Capacitor 50V AVX
827254244 C27 2200u 85° D16 / H25 mm Electrolytic Capacitor 35V
N.C. C28 N.C. N.C. D6.3 mm Chip Type Electrolytic Capacitor N.C. NIC
823436561 C29 100n X7R 1206 Ceramic Chip Capacitor 50V AVX
823436561 C30 100n X7R 1206 Ceramic Chip Capacitor 50V AVX
833053337 C31 100u 85° D6.3 mm Chip Type Electrolytic Capacitor 16V NIC
824672241 C32 220n 5% Step 5 mm Polyester Capacitor 63V TPC
823436561 C33 100n X7R 1206 Ceramic Chip Capacitor 50V AVX
823436561 C34 100n X7R 1206 Ceramic Chip Capacitor 50V AVX
823436553 C35 22n X7R 1206 Ceramic Chip Capacitor 50V AVX
824672225 C36 10n 5% Step 5 mm Polyester Capacitor 63V TPC
827254244 C37 2200u 85° D16 / H25 mm Electrolytic Capacitor 35V
823436561 C38 100n X7R 1206 Ceramic Chip Capacitor 50V AVX
827260928 C39 100u 85° D6.3 / H11 mm Electrolytic Capacitor 16V
824672231 C40 33n 5% Step 5 mm Polyester Capacitor 63V TPC
824672231 C41 33n 5% Step 5 mm Polyester Capacitor 63V TPC
824672231 C42 33n 5% Step 5 mm Polyester Capacitor 63V TPC
824672231 C43 33n 5% Step 5 mm Polyester Capacitor 63V TPC
833056113 C44 1u 85° D4 mm Chip Type Electrolytic Capacitor 50V NIC
823136525 C45 100p NP0 1206 Ceramic Chip Capacitor 50V AVX
823136525 C46 100p NP0 1206 Ceramic Chip Capacitor 50V AVX
823436561 C47 100n X7R 1206 Ceramic Chip Capacitor 50V AVX
823436561 C48 100n X7R 1206 Ceramic Chip Capacitor 50V AVX
823436553 C49 22n X7R 1206 Ceramic Chip Capacitor 50V AVX
828124246 C50 3300u 105° D16 / H25 mm Electrolytic Capacitor 16V
833053125 C51 10u 85° D4 mm Chip Type Electrolytic Capacitor 16V NIC
833053125 C52 10u 85° D4 mm Chip Type Electrolytic Capacitor 16V NIC
833053125 C53 10u 85° D4 mm Chip Type Electrolytic Capacitor 16V NIC
824672225 C54 10n 5% Step 5 mm Polyester Capacitor 63V TPC
833053337 C55 100u 85° D6.3 mm Chip Type Electrolytic Capacitor 16V NIC
833053337 C56 100u 85° D6.3 mm Chip Type Electrolytic Capacitor 16V NIC
823436553 C57 22n X7R 1206 Ceramic Chip Capacitor 50V AVX
823136529 C58 220p NP0 1206 Ceramic Chip Capacitor 50V AVX
823136529 C59 220p NP0 1206 Ceramic Chip Capacitor 50V AVX
823436553 C60 22n X7R 1206 Ceramic Chip Capacitor 50V AVX
823436553 C61 22n X7R 1206 Ceramic Chip Capacitor 50V AVX

MISCELLANEOUS
Code Ref.No. Nomenclature Selection Power/Case Description Volt M.Factory

872400205 For D1 Spacer H7 mm ABS Spacer G.T.

872400205 For D2 Spacer H7 mm ABS Spacer G.T.
838013225 DL1 Indicator Green/Red Housing Led Lamp COD:L-934EB/1G1HD Kingbright
N.C. FAN1 N.C. 2x2.50 mm Pitch N.C. N.C.
843060533 FAN2 Connector 2x2.50 mm Pitch Board to Wire Crimp Style Connector COD:EH25W-02 Adimpex
870250335 FE1 PCB Spacer ADS D6 / H3.5 mm Aluminium Ferrule G.T.
845710010 FUS1-A Fuse Holder Fuse Holder for ATC Fuse COD:CQ114 Omega
845710010 FUS1-B Fuse Holder Fuse Holder for ATC Fuse COD:CQ114 Omega
843030502 J1 Jumper 2x2.54 mm Pitch Pin Header Strip COD:APS2.54-SS6-2-G Adimpex
843030502 J2 Jumper 2x2.54 mm Pitch Pin Header Strip COD:APS2.54-SS6-2-G Adimpex
817030405 NTC1 NTC-22K Step 2.5 mm NTC Bead COD:2322 640 63223 Philips
864005121 For NTC1 Spacer D0.5 / H5 mm Sterling Spacer G.T.
864005121 For NTC1 Spacer D0.5 / H5 mm Sterling Spacer G.T.
472000310 For POT1 Shaft L22 mm Metal Shaft Nickel Plated G.T.
472000312 For POT2 Shaft L13 mm Metal Shaft Nickel Plated G.T.
872400205 For Q1 Spacer H7 mm ABS Spacer G.T.
872400205 For Q2 Spacer H7 mm ABS Spacer G.T.
872400205 For Q3 Spacer H7 mm ABS Spacer G.T.
872400205 For Q4 Spacer H7 mm ABS Spacer G.T.
872400205 For Q5 Spacer H7 mm ABS Spacer G.T.
872400205 For Q6 Spacer H7 mm ABS Spacer G.T.
843580010 RCA1 RCA Jack RCA Jack COD:JE0200590G Dae Ryung
844355820 SW1 Switch NS 8P2T Push Switch COD:PS-82D01 Seiko
844351510 SW2 Switch NS-Self Lock 2P2T Push Switch COD:PS-22F02 Seiko
844351510 SW3 Switch NS-Self Lock 2P2T Push Switch COD:PS-22F02 Seiko
843708161 TB1 Terminal Block 8 Poles Terminal Block TIPO 22 G.T.
840013066 TRF1 Transformer MB3 D31 / d19 / H13 mm Toroidal Core Transformer COD:840013066 G.T.

SERVICE MANUAL COD: 112042095 VERSION 0.0 8

 d - Component Side Layout Rev. 0

167,32 mm

91,44 mm

0 2003/08/07 ISSUED SPADONI TAMANTI GIACOMONI

850004810 / Layout Component Side Layout

850004810 1 1

F2_190-850004810-030807-P10-AA.CDR

SERVICE MANUAL COD: 112042095 VERSION 0.0 9

 e - Electrical Scheme Rev. 0

SERVICE MANUAL COD: 112042095 VERSION 0.0 10