SERVICE MANUAL

DV113S
 CONTENTS

1. SAFETY PRECAUTIONS 1

2. PREVENTION OF ELECTRO STATIC DISCHARGE(ESD)TO ELECTROSTATICALLY

SENSITIVE(ES)DEVICES 1

3. CONTROL BUTTON LOCATIONS AND EXPLANATIONS 2

4. PREVERTION OF STATIC ELECTRICITY DISCHARGE 3

5. ASSEMBLING AND DISASSEMBLING THE MECHANISM UNIT 4

5.1 OPTICAL PICKUP UNIT EXPLOSED VIEW AND PART LIST 4

5.2 BRACKET EXPLOSED VIEW AND PART LIST 6

5.3 MISCELLANEOUS 7

6. ELECTRICAL CONFIRMATION 8

6.1 VIDEO OUTPUT (LUMINANCE SIGNAL) CONFIRMATION 8

6.2 VIDEO OUTPUT(CHROMINANCE SIGNAL) CONFIRMATION 9

7. MPEG BOARD CHECK WAVEFORM 10

8. IC BLOCK DIAGRAM & DESCRIPTION 11

8.2 MT1389 19

8.3 U214 HY29F800 14

8.4 U203 SDRAM-HY57V1610D 17

9. SCHEMATIC & PCB WIRING DIAGRAM 19

10. SPARE PARTS LIST 32

1. SAFETY PREAUTIONS
1.1 GENERAL GUIDELINES
1. When servicing, observe the original lead dress. if a short circuit is found, replace all parts which have
been overheated or damaged by the short circuit.
2. After servicing, see to it that all the protective devices such as insulation barrier, insulation papers
shields are properly installed.
3. After servicing, make the following leakage current checks to prevent the customer from being exposed
to shock hazards.

2.PREVENTION OF ELECTRO STATIC DISCHARGE(ESD)TO

ELECTROSTATICALLY SENSITIVE(ES)DEVICES
Some semiconductor(solid state)devices can be damaged easily by static electricity. Such components
commonly are called Electrostatically Sensitive(ES)Devices. Examples of typical ES devices are integrated
circuits and some field-effect transistors and semiconductor chip components. The following techniques
should be used to help reduce the incidence of component damage caused by electro static discharge(ESD).
1. Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain
off any ESD on your body by touching a known earth ground. Alternatively, obtain and wear a commercially
availabel discharging ESD wrist strap, which should be removed for potential shock reasons prior to
applying power to the unit under test.
2. After removing an electrical assembly equipped with ES devices,place the assembly on a conductive
surface such as alminum foil, to prevent electrostatic charge buildup or exposure of the assembly.
3. Use only a grounded-tip soldering iron to solder or unsolder ES devices.
4. Use only an anti-static solder removal device. Some solder removal devices not classified as anti-static
(ESD protected)can generate electrical charge sufficient to damage ES devices.
5. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ES
devices.
6. Do not remove a replacement ES device from its protective package until immediately before you are
ready to install it. (Most replacement ES devices are packaged with leads electrically shorted together by
conductive foam, alminum foil or comparable conductive material).
7. Immediately before removing the protective material from the leads of a replacement ES device, touch
the protective material to the chassis or circuit assembly into which the device will be installed.
Caution
Be sure no power is applied to the chassis or circuit, and observe all other safety precautions.
8. Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise harmless motion
such as the brushing together of your clothes fabric or the lifting of your foot from a carpeted floor can
generate static electricity(ESD).

notice (1885x323x2 tiff)

1
 3.Control Button Locations and Explanations

Front Panel Illustration

2 3

4 5 6 7 8

POWER switch 4 OPEN/CLOSE button 7 MIC jack

2 Disc tray 5 PLAY/PAUSE button 8 MIC VOLUME button
3 IR SENSOR button 6 STOP button

2
 4.PREVENTION OF STATIC ELECTRICITY DISCHARGE

The laser diode in the traverse unit (optical pickup)may brake down due to static electricity of clothes or human
body. Use due caution to electrostatic breakdown when servicing and handling the laser diode.

4.1.Grounding for electrostatic breakdown prevention

Some devices such as the DVD player use the optical pickup(laser diode)and the optical pickup will be damaged
by static electricity in the working environment.Proceed servicing works under the working environment where
grounding works is completed.
4.1.1. Worktable grounding
1. Put a conductive material(sheet)or iron sheet on the area where the optical pickup is placed,and ground the
sheet.
4.1.2.Human body grounding
1 Use the anti-static wrist strap to discharge the static electricity from your body.

safety_3 (1577x409x2 tiff)

4.1.3.Handling of optical pickup

1. To keep the good quality of the optical pickup maintenance parts during transportation and before
installation, the both ends of the laser diode are short-circuited.After replacing the parts with new ones,
remove the short circuit according to the correct procedure. (See this Technical Guide).
2. Do not use a tester to check the laser diode for the optical pickup .Failure to do so willdamage the laser
diode due to the power supply in the tester.

4.2. Handling precautions for Traverse Unit (Optical Pickup)

1. Do not give a considerable shock to the traverse unit(optical pickup)as it has an extremely high-precise
structure.
2. When replacing the optical pickup, install the flexible cable and cut is short land with a nipper. See the
optical pickup replacement procedure in this Technical Guide. Before replacing the traverse unit, remove
the short pin for preventingstatic electricity and install a new unit.Connect the connector as short times as
possible.
3. The flexible cable may be cut off if an excessive force is applied to it.Use caution when handling the cable.
4. The half-fixed resistor for laser power adjustment cannot be adjusted. Do not turn the resistor.

3
5. Assembling and disassembling the mechanism unit

5.1 Optical pickup Unit Explosed View and Part List

Pic (1)

4
Materials to Pic (1)

No. PARTS CODE PARTS NAME Q ty

14692200 SF-HD60 1
1 1EA0311A06300 ASSY, CHASSIS, COMPLETE 1
2 1EA0M10A15500 ASSY, MOTOR, SLED 1
Or 1EA0M10A15501 ASSY, MOTOR, SLED 1
3 1EA2451A24700 HOLDER, SHAFT 3
4 1EA2511A29100 GEAR, RACK 1
5 1EA2511A29200 GEAR, DRIVE 1
6 1EA2511A29300 GEAR, MIDDLE, A 1
7 1EA2511A29400 GEAR, MIDDLE, B 1
8 1EA2744A03000 SHAFT, SLIDE 1
9 1EA2744A03100 SHAFT, SLIDE, SUB 1
10 1EA2812A15300 SPRING, COMP, TYOUSEI 3
11 1EA2812A15400 SPRING, COMP, RACK 1

21 1EA0B10B20100 ASSY, PWB 1

Or 1EA0B10B20200 ASSY, PWB 1

31 SEXEA25700--- SPECIAL SCREW BIN+-M2X11 3

32 SEXEA25900--- SPECIAL SCREW M1.7X2.2 2
33 SFBPN204R0SE- SCR S-TPG PAN 2X4 2
34 SFSFN266R0SE- SCR S-TPG FLT 2.6X6 1
35 SWXEA15400--- SPECIAL WASHER 1.8X4 X0.25 2

Note : This parts list is not for service parts supply.

5
5.2 Bracket Explosed View and Part List

Pic (2)
Materials to Pic(2)
1.bracket 14. front silicon rubber
2.belt 15. Back silicon rubber
3.screw 16. Pick-up
4.belt wheel 17. Pick-up
5.gearwheel 18. switch
6.iron chip 19. Five-pin flat plug
7. Immobility mechanism equipment 20. screw
8. Magnet 21. PCB
9. Platen 22. motor
10. Bridge bracket 23. Motor wheel
11. screw 24. screw
12. screw 25.tray
13. Big bracket

Before going process with disassembly and installation, please carefully both
peruse the chart and confirm the materials.

6
5.3 MISCELLANEOUS
5.3.1 Protection of the LD(Laser diode)

Short the parts of LD circuit pattern by soldering.

5.3.2 Cautions on assembly and adjustment

Make sure that the workbenches,jigs,tips,tips of soldering irons and measuring instruments are
grounded,and that personnel wear wrist straps for ground.

Open the LD short lands quickly with a soldering iron after a circuit is connected.

Keep the power source of the pick-up protected from internal and external sources of electrical
noise.
Refrain from operation and storage in atmospheres containing corrosive gases (such as H2S,SO2,
NO2 and Cl2)or toxic gases or in locations containing substances(especially from the organic silicon,cyan,
formalin and phenol groups)which emit toxic gases.It is particularly important to ensure that none of the
above substances are present inside the unit.Otherwise,the motor may no longer run.

7
6.Electrical Confirmation

6.1. Video Output (Luminance Signal) Confirmation

DO this confirmation after replacing a P.C.B.

Measurement point Mode Disc

Color bar 75% DVDT-S15

Video output terminal PLAY(Title 46):DVDT-S15 or
PLAY(Title 12):DVDT-S01 DVDT-S01

Measuring equipment,tools Confirmation value

200mV/dir,10 sec/dir 1000mVp-p±30mV

Purpose:To maintain video signal output compatibility.

1.Connect the oscilloscope to the video output terminal and terminate at 75 ohms.

2.Confirm that luminance signal(Y+S)level is 1000mVp-p±30mV

8
 6.2 Video Output(Chrominance Signal) Confirmation

Do the confirmation after replacing P.C.B.

Measurement point Mode Disc

Color bar 75% DVDT-S15

Video output terminal PLAY(Title 46):DVDT-S15 or
PLAY(Title 12):DVDT-S01 DVDT-S01

Measuring equipment,tools Confirmation value

Screwdriver,Oscilloscope
200mV/dir,10 sec/dir 621mVp-p±30mV

Purpose:To maintain video signal output compatibility.

1.Connect the oscilloscope to the video output terminal and terminate at 75 ohme.

2.Confirm that the chrominance signal(C)level is 621 mVp-p±30mV

9
7.MPEG BOARD CHECK WAVEFORM
7.1 27MHz WAVEFORM
DIAGRAM

7.2 ICVIPER22 PIN.5 WAVEFORM DIAGRAM

10
8.2 MT1389 MT1389
Progressive-Scan DVD Player SOC
Specifications are subject to change without notice

MediaTek MT1389 is a DVD player system-on-chip (SOC) which incorporates advanced features like high
quality TV encoder and state-of-art de-interlace processing. The MT1389 enables consumer electronics
manufacturers to build high quality, cost-effective DVD players, portable DVD players or any other home
entertainment audio/video devices.
Based on MediaTek’s world-leading DVD player SOC architecture, the MT1389 is the 3rd generation of the DVD
player SOC. It integrates the MediaTek 2nd generation front-end analog RF amplifier and the Servo/MPEG AV
decoder.
The progressive scan of the MT1389 utilized a proprietary advanced motion-adaptive de-interlace algorithm to
achieve the best movie/video playback. It can easily detect 3:2/2:2 pull down source and restore the correct
original pictures. It also supports a patent-pending edge-preserving algorithm to remove the saw-tooth effect.

Key Features
RF/Servo/MPEG Integration
CVBS, Y/C, High Performance Audio Processor
DVD
Component Motion-Adaptive, Edge-Preserving De-interlace
PUH
Module SDPIF 108MHz/12-bit, 6 CH TV Encoder
MT1389L
Applications
FLASH Audio DAC Standard DVD Players
Portable DVD Players

Front-panel
DRAM
Remote

DVD Player System Diagram Using MT1389

11
 MT1389
PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE

General Feature List

1024-bytes on-chip RAM
Super Integration DVD player single chip Up to 4M bytes FLASH-programming
High performance analog RF amplifier interface
Servo controller and data channel processing Supports 5/3.3-Volt. FLASH interface
MPEG-1/MPEG-2/JPEG video Supports power-down mode
Dolby AC-3/DTS/DVD-Audio Supports additional serial port
Unified memory architecture
Versatile video scaling & quality DVD-ROM/CD-ROM Decoding Logic
enhancement High-speed ECC logic capable of correcting
OSD & Sub-picture one error per each P-codeword or
2-D graphic engine Q-codeword
Built-in clock generator Automatic sector Mode and Form detection
Built-in high quality TV encoder Automatic sector Header verification
Built-in progressive video processor Decoder Error Notification Interrupt that
Audio effect post-processor signals various decoder errors
Audio input port Provide error correction acceleration

High Performance Analog RF Amplifier Buffer Memory Controller

Programmable fc Supports 16Mb/32Mb/64Mb/128Mb SDRAM
Dual automatic laser power control Supports 16-bit SDRAM data bus
Defect and blank detection Provide the self-refresh mode SDRAM
RF level signal generator Block-based sector addressing
Support 3.3 Volt. DRAM Interface
Speed Performance on Servo/Channel Decoding
DVD-ROM up to 4XS Video Decode
CD-ROM up to 24XS Decodes MPEG1 video and MPEG2 main level,
main profile video (720/480 and 720x576)
Channel Data Processor Smooth digest view function with I, P and B
Digital data slicer for small jitter capability picture decoding
Built-in high performance data PLL for Baseline, extended-sequential and
channel data demodulation progressive JPEG image decoding
EFM/EFM+ data demodulation Support CD-G titles
Enhanced channel data frame sync protection
& DVD-ROM sector sync protection Video/OSD/SPU/HLI Processor
Arbitrary ratio vertical/horizontal scaling of
Servo Control and Spindle Motor Control video, from 0.25X to 256X
Programmable frequency error gain and 65535/256/16/4/2-color bitmap format OSD,
phase error gain of spindle PLL to control 256/16 color RLC format OSD
spindle motor on CLV and CAV mode Automatic scrolling of OSD image
Built-in ADCs and DACs for digital servo Slide show transition as DVD-Audio
control Specification
Provide 2 general PWM
Tray control can be PWM output or digital 2-D Graphic Engine
output Support decode Text and Bitmap
Support line, rectangle and gradient fill
Embedded Micro controller Support bitblt
Built-in 8032 micro controller Chroma key copy operation
Built-in internal 373 and 8-bit programmable Clip mask
lower address port

12
 MT1389
PRELIMINARY, SUBJECT TO CHANGE WITHOUT NOTICE MTK CONFIDENTIAL, NO DISCLOSURE

Audio Effect Processing TV Encoder

Dolby Digital (AC-3)/EX decoding Six 108MHz/12bit DACs
DTS/DTS-ES decoding Support NTSC, PAL-BDGHINM, PAL-60
MLP decoding for DVD-Audio Support 525p, 625p progressive TV format
MPEG-1 layer 1/layer 2 audio decoding Automatically turn off unconnected channels
MPEG-2 layer1/layer2 2-channel audio Support PC monitor (VGA)
High Definition Compatible Digital (HDCD) Support Macrovision 7.1 L1, Macrovision
Windows Media Audio (WMA) 525P and 625P
Advanced Audio Coding (AAC) CGMS-A/WSS
Dolby ProLogic II Closed Caption
Concurrent multi-channel and downmix out
IEC 60958/61937 output Progressive Output
- PCM / bit stream / mute mode Automatic detect film or video source
- Custom IEC latency up to 2 frames 3:2 pull down source detection
Pink noise and white noise generator Advanced Motion adaptive de-interlace
Karaoke functions Edge Preserving
- Microphone echo Minimum external memory requirement
- Microphone tone control
- Vocal mute/vocal assistant Audio Input
- Key shift up to +/- 8 keys Line-in/SPDIF-in for versatile audio
- Chorus/Flanger/Harmony/Reverb processing
Channel equalizer
3D surround processing include virtual Outline
surround and speaker separation 256-pin LQFP package
3.3/1.8-Volt. Dual operating voltages

13
 8.3 U214 HY29F800

KEY FEATURES
n 5 Volt Read, Program, and Erase n Sector Protection
– Minimizes system-level power requirements – Any combination of sectors may be
n High Performance locked to prevent program or erase
– Access times as fast as 55 ns operations within those sectors
n Low Power Consumption n Temporary Sector Unprotect
– 20 mA typical active read current in byte – Allows changes in locked sectors
mode, 28 mA typical in word mode (requires high voltage on RESET# pin)
– 35 mA typical program/erase current n Internal Erase Algorithm
– 5 µA maximum CMOS standby current – Automatically erases a sector, any
n Compatible with JEDEC Standards combination of sectors, or the entire chip
– Package, pinout and command-set n Internal Programming Algorithm
compatible with the single-supply Flash – Automatically programs and verifies data
device standard at a specified address
– Provides superior inadvertent write n Fast Program and Erase Times
protection – Byte programming time: 7 µs typical
n Sector Erase Architecture – Sector erase time: 1.0 sec typical
– Boot sector architecture with top and – Chip erase time: 19 sec typical
bottom boot block options available n Data# Polling and Toggle Status Bits
– One 16 Kbyte, two 8 Kbyte, one 32 Kbyte – Provide software confirmation of
and fifteen 64 Kbyte sectors in byte mode completion of program or erase
– One 8 Kword, two 4 Kword, one 16 Kword operations
and fifteen 32 Kword sectors in word mode n Ready/Busy# Output (RY/BY#)
– A command can erase any combination of – Provides hardware confirmation of
sectors completion of program and erase
– Supports full chip erase operations
n Erase Suspend/Resume n Minimum 100,000 Program/Erase Cycles
– Temporarily suspends a sector erase n Space Efficient Packaging
operation to allow data to be read from, or – Available in industry-standard 44-pin
programmed into, any sector not being PSOP and 48-pin TSOP and reverse
erased TSOP packages

19 8
A[18:0] DQ[7:0]

7
CE# DQ[14:8]

OE# DQ[15]/A-1

WE#

RESET# RY/BY#

BYTE#

14
BLOCK DIAGRAM
DQ[15:0]

A[18:0], A-1 STATE

CONTROL
ERASE VOLTAGE I/O BUFFERS
DQ[15:0] GENERATOR AND
SECTOR SWITCHES
WE# COMMAND
REGISTER I/O CONTROL
CE#
OE# DATA LATCH
PROGRAM
BYTE# VOLTAGE
RESET# GENERATOR
RY/BY#
Y-DECODER Y-GATING

ADDRESS LATCH
V C C DETECTOR TIMER A[18:0], A-1 8 Mb FLASH
X-DECODER MEMORY
ARRAY

15
PIN CONFIGURATIONS

RY/BY# 1 44 RESET# A15 1 48 A16

A18 2 43 WE# A14 2 47 BYTE#
A17 3 42 A8 A13 3 46 V SS
A7 4 41 A9 A12 4 45 DQ15/A-1
A6 5 40 A10 A11 5 44 DQ7
A5 6 39 A11 A10 6 43 DQ14
A4 7 38 A12 A9 7 42 DQ6
A3 8 37 A13 A8 8 41 DQ13
A2 9 36 A14 NC 9 40 DQ5
PSOP44

A1 10 35 A15 NC 10 39 DQ12
A0 11 34 A16 WE# 11 38 DQ4
CE# 12 33 BYTE# RESET# 12 Standard 37 V CC
V SS 13 32 V SS NC 13 36 DQ11
OE# 14 31 DQ15/A-1 NC 14 TSOP48 35 DQ3
DQ0 15 30 DQ7 RY/BY# 15 34 DQ10
DQ8 16 29 DQ14 A18 16 33 DQ2
DQ1 17 28 DQ6 A17 17 32 DQ9
DQ9 18 27 DQ13 A7 18 31 DQ1
DQ2 19 26 DQ5 A6 19 30 DQ8
DQ10 20 25 DQ12 A5 20 29 DQ0
DQ3 21 24 DQ4 A4 21 28 OE#
DQ11 22 23 V CC A3 22 27 V SS
A2 23 26 CE#
A1 24 25 A0

A16 1 48 A15
BYTE# 2 47 A14
V SS 3 46 A13
DQ15/A-1 4 45 A12
DQ7 5 44 A11
DQ14 6 43 A10
DQ6 7 42 A9
DQ13 8 41 A8
DQ5 9 40 NC
DQ12 10 39 NC
DQ4 11 38 WE#
V CC 12 Reverse 37 RESET#
DQ11 13 36 NC
DQ3 14 TSOP48 35 NC
DQ10 15 34 RY/BY#
DQ2 16 33 A18
DQ9 17 32 A17
DQ1 18 31 A7
DQ8 19 30 A6
DQ0 20 29 A5
OE# 21 28 A4
V SS 22 27 A3
CE# 23 26 A2
A0 24 25 A1

16
8.4 U203 SDRAM-HY57V1610D

DESCRIPTION

THE Hynix HY57V161610D is a 16,777,216-bits CMOS Synchronous DRAM, ideally suited for the Mobile applications
which require low power consumption and industrial temperature range. HY57V161610D is organized as 2banks of
524,288x16.

HY57V161610D is offering fully synchronous operation referenced to a positive edge clock. All inputs and outputs are
synchronized with the rising edge of the clock input. The data paths are internally pipelined to achieve very high band-
width. All input and output voltage levels are compatible with LVTTL.

Programmable options include the length of pipeline (Read latency of 1,2 or 3), the number of consecutive read or
write cycles initiated by a single control command (Burst length of 1,2,4,8 or full page), and the burst count
sequence(sequential or interleave). A burst of read or write cycles in progress can be terminated by a burst terminate
command or can be interrupted and replaced by a new burst read or write command on any cycle. (This pipeline
design is not restricted by a `2N` rule.)

FEATURES

• Single 3.0V to 3.6V power supply Note1) • Auto refresh and self refresh

• All device pins are compatible with LVTTL interface • 4096 refresh cycles / 64ms

• JEDEC standard 400mil 50pin TSOP-II with 0.8mm • Programmable Burst Length and Burst Type
of pin pitch
- 1, 2, 4, 8 and Full Page for Sequence Burst
• All inputs and outputs referenced to positive edge of
- 1, 2, 4 and 8 for Interleave Burst
system clock

• Programmable C A S Latency ; 1, 2, 3 Clocks

• Data mask function by UDQM/LDQM

• Internal two banks operation

ORDERING INFORMATION

Part No. Clock Frequency Organization Interface Package

HY57V161610DTC-55I 183MHz

HY57V161610DTC-6I 166MHz
400mil
2Banks x 512Kbits x 16 LVTTL
50pin TSOP II
HY57V161610DTC-7I 143MHz

HY57V161610DTC-10I 100MHz

This document is a general product description and is subject to chage without notice. Hyundai Electronics does not assume any
responsibility for use of circuits described. No patent licenses are implied
Rev. 0.2/Aug.01

17
PIN CONFIGURATION

VDD 1 50 VSS
DQ0 2 49 DQ15
DQ1 3 48 DQ14
V S S Q 4 47 V S S Q
DQ2 5 46 DQ13
DQ3 6 45 DQ12
VDDQ 7 44 VDDQ
DQ4 8 43 DQ11
DQ5 9 42 DQ10
V S S Q 10 41 V S S Q
DQ6 11 40 DQ9
DQ7 12 39 DQ8
50pin TSOP-II
VDDQ 13 38 VDDQ
400mil x 825mil
LDQM 14 0.8mm pin pitch 37 N C
W E 15 36 UDQM
CAS 16 35 CLK
RAS 17 34 CKE
C S 18 33 N C
A11 19 32 A9
A10 20 31 A8
A0 21 30 A7
A1 22 29 A6
A2 23 28 A5
A3 24 27 A4
VDD 25 26 VSS

PIN DESCRIPTION

PIN PIN NAME DESCRIPTION

The system clock input. All other inputs are referenced to the SDRAM on the
CLK Clock
rising edge of CLK.

Controls internal clock signal and when deactivated, the SDRAM will be one
CKE Clock Enable
of the states among power down, suspend or self refresh.

CS Chip Select Command input enable or mask except CLK, CKE and DQM

BA Bank Address Select either one of banks during both R A S a n d C A S activity.

Row Address : RA0 ~ RA10, Column Address : CA0 ~ CA7

A0 ~ A10 Address
Auto-precharge flag : A10

Row Address Strobe,

R A S , C A S and W E define the operation.
RAS, CAS, W E Column Address Strobe,
Refer function truth table for details
Write Enable

LDQM, UDQM Data Input/Output Mask DQM control output buffer in read mode and mask input data in write mode

DQ0 ~ DQ15 Data Input/Output Multiplexed data input / output pin

V D D /V S S Power Supply/Ground Power supply for internal circuit and input buffer

V D D Q /V S S Q Data Output Power/Ground Power supply for DQ

NC No Connection No connection

18
 １ ２ ３ ４ ５ ６

Ａ
Ａ

Ｂ
Ｂ
FRONT SCHEMATIC DIAGRAM
9. SCHEMATIC & PCB WIRING DIAGRAM

U403
HS0038A2
K401 IR 3
DST R416
Ｃ C405 Ｃ
4.7K 1
K402 2
DCK R417 VCC
104
4.7K
K403 TC407
DAT R418
R415 100uF/16V
100
4.7K VCC

19
1
D401
IR 1
IN4148

K A
VCC 2
GND 3 Ｄ
XS401
Ｄ DST 4
XS06

2
DCK 5
DAT 6

Ｅ
Ｅ

DV1001RU ＢＢＫ
更改 数量 更改单号 签　名 日期
Ｆ 设　　计 主 面 板 电 路原 理 图 比例 质量 数量 Ｆ
审　　核 第　１　张 共　１　张 版次：1.0
标准化
板号 : 4911S-0 广东步步高电子工业有限公司ＡＶ厂
批　　准
１ ２ ３ ４ ５ ６
FRONT SCHEMATIC DIAGRAM

20
 1 2 3 4 5 6

A
A
POWER SCHEMATIC DIAGRAM

L505
10uH/1A B

2
B +9V
D508
R503 C502 HER105
D503 ! TC503 TC504
D502 39K/2W 103/1KV C508
1N4007 470uF/16V 470uF/16V

A K
1N4007 104

T501 10

1
1 9
D501 D504 TC501 C503 D505 8
1N4007 101/1KV D510 SR560 L507 10uH/2A
47uF/400V HER107 2 +5V
1N4007
3 TC505 TC506 C510
7 1000uF/10V 1000uF/10V 104
4
+3.3V
5 D509 D513
6 1N4007 1N4007 TC510
! R505 D506 1000uF/10V C
C 10ohm HER105 EEL19H

FB
C504 TC502

L503
104 47uF/50V

D511
HER105
R511

21
5
6
7
8
330R/1W
R512 -9V
9.1K

D
D
D
D
4 TC512 R507 R508 TC513
VDD ZD502
3 47uF/50V 1K 3.3K
FB 9.1V/1W
U501 100uF/16V

S
S
VIPER22 R506
L501 330
C506
C515

1
2
473 D
D ! BC501
104
~275V 104
!
U502
2501 U503 K
! R501 4 1 LM431A R R509
680K 2W 10K
! 3 2 A

! +9V 1
BCN502 ! BC503 -9V 2
SW-SPST BCN501
F501 ! ~400V 221 GND 3
T1.6A/250V +5V 4 CN502
~220V
GND 5
XS07
+3.3V 6
GND 7 E
E +5V

2
1
R517
BCN501 330R
1
~220V
GND 2
CN501
-9V 3
XS04
+9V 4

DVD-VIPER22 BBK
更改 数量 更改单号 签 名 日期
F 设 计 开关电源电原理图 比例 质量 数量 F
审 核 第 1 张 共 1 张 版次： 1.0
标准化
板号: 5501A-3 广东步步高电子工业有限公司AV厂
批 准
1 2 3 4 5 6
POWER BOARD SCHEMATIC DIAGRAM

22
 1 2 3 4 5 6

A
A
OK

R609 30K

R607
TC605 1K C605 101
2 1
R613
30K 27K
22U/16V R629

4
MIC602
C607 101 C620 101
7 TC601 R603 2 TC603
6 4.7U/16V 560R 1 -9VA
5 3 B
B 4 4.7U/16V

4
3 L602 TC611
FB U601A R628
2 4.7K 6

8
1 R601 C603 R605 4558 2 TC613 7
R61415K
22K 103 10K 1 4.7U/16V 5
+9VA 3 U602B TC610 R626
U602A
+5V 4.7U/16V 4558 4.7uF/16V 1K
4558 C608 C619
102

3
8
392
R623
4.7k R612
R619 VR602 10K +9VA
1K 2
DET
TC621
10K
4.7uF/16V

1
R610

10K
30K

R61710K
R618 R624 R621 C615 C616 C
C 15K 10K 10K 392 103

R6224.7K
R616 5.6K
C612 C613 C614

R620
R608 TC607 C610
20K 4.7uF/16V 561 561 104 104
R633 R632
OK BOARD SCHEMATIC DIAGRAM

16
15
14
13
12
11
10
9
10R1/6W 10R1/6W
+9V +9VA -9V -9VA
U603

23
PT2399
TC615 C601 TC616 C602

OP2-IN
OP1-IN

LPF1-IN
LPF2-IN
100U/16V 104 100U/16V 104

OP2-OUT
OP1-OUT

LPF1-OUT
LPF2-OUT
D
D

VDD
REF
AGND
DGND
CLKO
VCO
CC1
CC2

1
2
3
4
5
6
7
8

+5V
DET 6
OK 5
AGND 4 XS601
+9V 3 XS06
-9V 2 TC608 C609
+5V 1 TC609 R615
22uF/16V 104 47uF/16V
10K
C622 C623
104 104

E
E

DV939 BBK
更改 数量 更改单号 签 名 日期
F 设 计 MIC板电原理图 比例 质量 数量 F
审 核 第 1 张 共 1 张 版次： 1.0
标准化
板号:6911-0 广东步步高电子工业有限公司AV厂
批 准
1 2 3 4 5 6
OK BOARD SCHEMATIC DIAGRAMDIAGRAM

24
 １ ２ ３ ４ ５ ６

JK701 Ａ
Ａ
L L705 L# 1
VCC +10V A+10V
R709 FB
C705
R704 330R R708 102 2
4.7K 33R
R705 R L706 R# 3
75R VCC FB
C706
R710 102
PDAT0 V702
2.2K 8050 AGND
V701
8050 4
AGND
Ｂ
C716 5
Ｂ VGND
A+10V 104 A+10V
SPDIF R701 330R 6
VGND
R711 JK706 C710 R702
1K R# L713 FCM 1
A(B)OUT 104
2 91R
A(B)IN VGND RCA-407
L# 3 A(A)OUT
R712 L714 FCM A-COM 4
2.2K 5
PDAT2 V703 RETURN 6
A(A)IN
8050 Pb- AGND 7 BLUE I/O
FUNC SW 8
9
RETURN 10
CONT C728
AGND Y- 11
OUTPUT BOARD SCHEMATIC

GREEN I/O 104

NC 12
13
XS7011 PDAT2 RETURN 14
2 PDAT1 Pr- 15 RETURN R721 0R Ｃ
Ｃ RED I/O
3 SPDIF BLK I/O 16 Y1 G L709 Y-
4 VCC 17 RETURN FBSMT
5 Y 18
6 19 TRTURN TC702
V-OUT 1000uF/16V

25
7 C V-IN 20
8 C707 21
105 GND
9 Pr
10 VJS3921
11 Y1 VGND
12
13 Pb
14 VGND VGND AGND
15 VIEDO R720 0R
16 PDAT0 Pb B L707 Pb-
17 L FBSMT
18
19 R TC703
220uF/16V
20 Ｄ
Ｄ 21 SL R707 0R
22 L708
23 SR Pr R Pr-
24 FBSMT
TC704
25 CC 220uF/16V
26
27 LFE
28 +10V
XS28 R715 0R

AGNDVGND R714 0R

R713 0R JK703B
R717 S-OUT
0R
AGND VGND

R706 L710 Ｅ
VIEDO 5
Ｅ
2.2R FBSMT
TC701 220uF 6
7

R718 VGND
0R
3

L711 JK703A
TC705 FBSMT
Y 220uF/16V 2

L712
C R719 0R 1
FBSMT
220uF/16V TC706 LFDV965
4

S-VIDEO 更改 数量 更改单号 签　名 日期 ＢＢＫ

Ｆ VGND
设　　计 AV 输出板原理图 比例　１：１ 质量 数量 Ｆ
审　　核 第　１　张 共　１　张 版次：1.0
标准化
板号: 7969SB 广东步步高电子工业有限公司ＡＶ厂
批　　准
１ ２ ３ ４ ５ ６
OUTPUT BOARD SCHEMATIC

26
 １ ２ ３ ４ ５ ６

2
C

1 B C E 3

2SB1132 Ａ
AVCC -12V +12V VCC 3.3V MO-VCC A5V
Ａ 24 GND-LD L301 FBSMT LDO-V33
23 LD-DVD L303 10uH LD-DVD
22 TC302 1 L218 FB MIC-DET
FBSMT R301
21 HFM L304 4.7R 47uF/10V 2 L219 FB OKA L209 FBSMT
20 MD L305 FBSMT MDI V301 3
19 LD-CD L306 10uH LD-CD 2SB1132-S LDO2 4 L220 FB INTEL 4M(28F400): VCC
18 VR-DVD L307 FBSMT VR-DVD 5 L221 FB OTHER TPYE 8M：DV33
17 VR-CD FBSMT VR-CD 6 L302
L308 FB
16 V302 LDO-V33 XS203 7 L222 FB
15 E L310 0R E 2SB1132-S 2.5MM 8
14 AVCC FBSMT 9 L223 FB VCC L204 VD
L311 TC303 FBSMT(DNS)
XS301 13 Vref FBSMT V20 R302 10
L313 4.7R 47uF/10V
12 GND-PD 11 L224 FB

2
24P0.5mm AVCC L206
11 F L312 0R F LDO1 12 DV33
FBSMT
10 B L314 0R B 13 C268 C269 C270 C271 TC207
9 A L316 0R A L205 104 104 104 104 220uF/10V C295
R204 C296
8 RF L317 0R RFO FB 104 TC208 C273 TC237
D 0R 104 Ｂ
7 CD/DVD L318 FBSMT IOA 220uF/10V 104 47uF/10V
0R 3
Ｂ 6 D L319 D
5 C L320 0R C G S LDO-V33 VCC
1 2
FBSMT

1
4 TK- L321 TK- VCC
3 TK+ L322 FBSMT TK+ 2SK3018

2
2
2 FC+ L323 FBSMT FC+ R309 R303
1 FC- L324 FBSMT FC-
R308 10K 10K(DNS) 2967D-1 在2967D-0 的基础上加入了蓝色标识的电阻R204 、L205
1 MIC-DET
100K
IOA 1 1 2 OKA
DVD: 0V
AVCC 3
R310 CD: +3.3V XS304

3
3
100K V304 V303 4
3 R311 +12V
2SK3018-S 2SK3018-S IOA L309 6P2.0mm 5
C LDO-V33 -12V
C328 C301 TC301 C311 C329 C312 FBSMT 6
10K VCC
104 104 220uF/10V 104 104 104 1 V305
B E 2
2N3904-S C345
2N3904 TC305
104
MIAN SCHEMATIC DIAGRAM

220uF/10V

MO-VCC L226 SD33 SD33

FB
Ｃ Ｃ
R304 1R TK- 15 14 FC+ R306 1R C2140 C2141 C2142 C2143 C2144 C2145
VOTK+ VOFC+ C249
16 13 FC- C245 C246 C247 C248 C250 C251 C252 TC212
R341 VOTK- VOFC- 104 104 104
SL+ 17 12 SP- 104 104 104 104 104 104 104 104 220uF/10V 104 104 104
0R(nc) VOLD+ VOSL+
R305 1R SL- 18 11 SP+ R307 1R
VOLD- VOSL-
19 10 OUT5+
PGND PGND
TK+ 20 9 OUT5-
VINFTK PVCC1
R340 21 8 MO-VCC R351 0R GND RFV33 RFVDD3 PLLVDD3
PVCC2 VCC L233 L208 R206
0R TC304 C302 C303 OUT5+ R350 0R(nc) LOAD+ FBSMT FBSMT 4.7R
30 29 GND
GND2 GND1

27
47uF/10V 104 104 R349 0R MO-VCC
22 7 REV TC214 C234
PREGND VINFFC OUT5- R348 0R(nc) LOAD-
FMSO 23 6 FWD 100uF/10V 104
VINLD VOSL C214 C215 C221
C304 R312 24 5 SLIN2 R347 0R FC-
CTK2 VINSL- 104 103 222
151 20K 25 4 FB1
CTK1 VINSL+ REV R346 10K(nc) TRCLOSE
TRSO 26 3 CF2
VINTK CF2
C305 V1P4 27 2 CF1 R345 10K(nc) TROPEN
BIAS CF1
104 STBY 28 1 FOSO
STBY VINFC FWD R314 10K DMSO
DV33 DACVDD3 APLLVDD3 Ｄ
0R R315 L229 L227 L228
Ｄ R313 10K U302 SLIN2 R344
20K FB FBSMT FBSMT
BA5954/ AT5665 10K
R343 0R(nc) FC- C211
C207 C208 C209 C210 C212 C213 TC203 C244 TC211 C240
R330 10K
FB1 R342 0R V1P4 104 104 104 104 104 104 104 47uF/10V 104 47uF/10V 104
DV33
1 SL+
C307 CF2 CF1 ADACVDD3
2 SL-
222
3 LIMIT R316
XS303 OPO C306
4 C313 104 20K 151
6P2.0mm 5 SP+ L207
ADIN 3.3V V18 RFV18 C294 TC245
6 SP- L215 L234 10uH
682 220uF/10V
R321 1R R317 R331 FBSMT FBSMT
3 2
680K/1% 0R IN OUT TC210
C308
GND

R322 1R(DNS) C229 1000uF/10V(DNS)

101(DNS) C235 C236 C237 C238 C239 C226
R320 104 TC209 104 104 104 104 104 104
R319 150K R242 220uF/10V
1

150K OP- 3.3K

OP+
U209 Ｅ
Ｅ C310
LM1117MP-ADJ R243
R318
222 1.5K
680K/1%
V1P4

DV33 MO-VCC

TC308
C309 TC309
47uF/10V
104 V306 V309 47uF/10V
R329 R328
8550D 8550D
10K 10K R323 R324
1K 1K
1 LOAD-
2 LOAD+
XS302 3 TROUT
5P2.0mm 4
R325 R326
5 TRIN DV967(MTK1389D + SANYO)
330R 330R 更改 数量 更改单号 签　名 日期 ＢＢＫ
TROPEN V307 V308 TRCLOSE
C315 C314 C327 C326 8050D 8050D
Ｆ 设　　计 解码 &伺服电原理图 比例 质量 数量 Ｆ
104 104 104 104 V310 TROPEN
2N3904-S 审　　核 第　１　张 共　５　张 版次： 2.0
R327 R332
2.2R\1/4W 10K 标准化
板号： 2967D-1 广东步步高电子工业有限公司ＡＶ厂
批　　准
１ ２ ３ ４ ５ ６
 １ ２ ３ ４ ５ ６

DV33
V1P4 V20 V2P8 C218 TC202 R214 2K(NC)
C222 TC201 C233
U202 22pF 0.47(DNS) 10uF/16V R281
10uF/16V C217 510R 391
AT24C02/X4050 R259 R260 152 2.2M
C230 1K 1K PLLVDD3 RFV18 APLLVDD3 JITFO JITFN
1 8 104 TC204 C243 TC205 C242 TC206 C241
2
DC/NC VCC
7 47uF/10V 104 47uF/10V 104 47uF/10V 104 V1P4 ADACVDD3 DACVDD3
Ａ
Ａ RST_/NC RST/WP

C228 104
XI
XO
3 6 SCL
WP/RST_ SCL R215 1K

C223 102
R227

JITFN
JITFO
FS0
ALRCK
4 5 SDA

ASPDIF
ASDAT2
ASDAT1
ASDAT0
VSS SDA 750K/1%

AL
AR
Y6
Y5
Y4
Y3
MCDATA
RFVDD3

R223 15K
C225 333
C232 C267 DV33

R224 100K
C220 473

C227 104
C219 473
221(DNS) 221(DNS) C216 104

C224 104

216
215
214
213
212
211
210
209
208
207
206
205
204
203
202
201
200
199
198
197
196
195
194
193
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
ACLK R291 33R SACLK
WE# R268 33R DWE# ABCK R292 33R SBCLK
CAS# R267 33R DCAS# ALRCK R293 33R SLRCK R216

R
B
G
FS

AL
AR
RAS# R266 33R DRAS# 4.7K

OSP
OSN

IREF
VCM

LPFIP
JITFN
JITFO
VREF
CS# 33R DCS#

RFGC
LPFIN
CVBS
SPDIF
R265

LPFOP
XTALI

LPFON

HRFZC
XTALO
C C201 105

AVDD3
RFGND
PLLVSS
DVDD3
ALRCK

CRTPLP
R201: 5.1 声道

RFRPAC
RFRPDC
RFVDD3
ADCVSS
APLLVSS

PLLVDD3
APLLCAP

RFVDD18
RFGND18
ASDATA3
ASDATA2
ASDATA1
ASDATA0

DACVSSA
DACVSSB
DACVSSC

ADCVDD3
IDACEXLP
MC_DATA
R202: 内置2 声道 1

ADACGND
APLLVDD3
DACVDDA
DACVDDB
DACVDDC
B C202 105 AGND Ｂ

ADACVDD3
2 162 ACLK
33R R201 0R DVDA ACLK
Ｂ DCKE R264 SDCKE AL RST#
A C203 105
3
DVDB ABCK
161 ABCK
DCLK R263 33R SDCLK 4 160
33R R202 0R(DNS) DVDC DVSS
BA0 R262 DBA0 5 159 TROUT
33R D C204 105 DVDD GPIO5
BA1 R261 DBA1 6 158 TRIN
R294 33R DVDRFIP GPIO4
ASDAT0 SDAT0 7 157 LIMIT
RFO C205 105 DVDRFIN GPIO3
ASDAT1 R295 33R SDAT1 C 8 156
MA DVDD18 V18
ASDAT2 R296 33R SDAT2 B 9 155 MA4
MB RA4
A 10 154 MA5
C206 MC RA5
D 11 153 MA6
101(DNS) MD RA6
SUBA 12 152 MA7
SA RA7
SUBB 13 151
SB DVDD3
SUBC 14 150 MA8
SC RA8
SUBD 15 149 MA9
SD RA9
16 148 MA11
CDFON RA11
FOSO R336 20K FOO FOO: FOCUS SERVO OUTPUT 17 147 DCKE
CDFOP CKE
TRSO R335 18K TRO TRO: TRACKING SERVO OUTPUT E 18 146 DCLK
TNI RCLK
FMSO R334 15K FMO FMO: FEED MOTOR CONTROL F 19 145
TPI DVSS
DMSO R333 10K DMO DMO: DISK MOTOR CONTROL MDI 20 144 MA3
MDI1 RA3
21 143 Ｃ
MDI2 DVSS
Ｃ C319 C318 C317 C316 LDO2 22
LDO2 U201 RA2
142 MA2
LDO1 23 141 MA1
331 331 104 153 LDO1 RA1
V1P4 24 140 MA0
RFVDD3 SVDD3 MT1389D RA0
RFOP 25 139 MA10
CSO/RFOP RA10
RFON 26 138

28
RFLVL/RFON DVDD3
27 137 BA1
SGND MT1389D SMD LQFP-216_0 BA1
V2P8 28 136 BA0
V2REFO BA0
V20 29 135 CS#
V20 RCS#
DV33 V1P4 30 134 RAS#
FEO: FOCUS ERROR MONITOR OUTPUT VREFO RAS#
FEO 31 133
TEO: TRACKING ERROR MONITOR OUTPUT FEO DVDD18
TEO 32 132 CAS#
TEO CAS#
TEZISLV 33 131 WE#
TEZISLV RWE#
R252 VD201 OPO 34 130
C320 OP_OUT DVSS
10K 1N4148 OP- 35 129 DQM1
104 OP_INN DQM1
OP+ 36 128 DQ8
OP_INP RD8
Q204 U205C DMO 37 127 DQ9
DMO RD9
9015C-S HCU04 FMO 38 126 DQ10
FMO RD10
C321 TROPEN 39 125 DQ11
R337 R338 TROPENPWM RD11
R253 5 6 URST# V1P4 40 124 DQ12 Ｄ
PWMOUT1/ADIN0 RD12
Ｄ 0R(DNS) TRO 41 123
R255 (DNS) (DNS) TRO DVDD3
(DNS) FOO 42 122 DQ13
TC217 R254 33R FOO RD13
1K ADIN 43 121 DQ14
10uF/16V C272 FG/ADIN1 RD14
VSYNC 44 120
102 R339 GPIO0 DVSS
0R HSYNC 45 119 DQ15
GPIO1 RD15
STBY 46 118 DQ0
GPIO2 RD0
A2 47 117 DQ1
IOA2 RD1
48 116 DQ2
DVDD18 RD2
A3 49 115
IOA3 DVSS
A4 50 114 DQ3
IOA4 RD3
A5 51 113 DQ4
IOA5 RD4
A6 52 112 DQ5
IOA6 RD5
A7 53 111 DQ6
IOA7 RD6
A8 54 110 DQ7
HIGHA0 RD7
109 DQM0
DQM0

IOA18
DVSS
IOA19
DVDD3
IOWR#
A16
DVDD3
HIGHA7
HIGHA6
HIGHA5
HIGHA4
HIGHA3
HIGHA2
HIGHA1
IOA20
IOCS#
DVSS
IOA1
IOOE#
DVSS
AD0
AD1
AD2
AD3
AD4
AD5
AD6
IOA21
ALE
DVDD18
AD7
A17
DVDD3
IOA0
UWR#
URD#
UP1_2
UP1_3
GPIO6
UP1_4
UP1_5
UP1_6
DVSS
UP1_7
UP3_0
UP3_1
UP3_4
UP3_5
GPIO7
ICE
PRST#
IR
INT0#
DVDD3

Ｅ
Ｅ

55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99

LQFP216/SMD
100
101
102
103
104
105
106
107
108

V18 DV33
DV33
VCC R230 XI
10K(DNS) R229 U205A R274

14
4.7K
7 IR HCU04 C274 10K(NC)
DV33
6 104
5 1 2 3 4 XTALI MIC-DET-IN MIC-DET
4 L230 FBSMT VSTB
XS201 R205
3 L231 FBSMT VSCK U205B R222
XS07 R245 0R
FBSMT R247

7
A18
A19
PWR#
A16
A15
A14
A13
A12
A11
A10
A9
A20
PCE#
A1
PRD#
AD0
AD1
AD2
AD3
AD4
AD5
AD6
FS1
ALE
AD7
A17
A0
UWR#
URD#
LCDIN
VSCK
IOA
VSTB
VSDA
SCL
SDA
MIC-DET-IN
MUTE-DAC
RXD
TXD
TRCLOSE
ICE
URST#
IR
INT0#

2 L232 VSDA HCU04 0R

R244
0R(DNS)
0R R246
1 L217 FBSMT LCDIN 0R
100K 2967D-1 在2967D-0 的基础上加入了蓝色标识的电阻R281 、R205 、R274
XI

C263 C264 C265 C266 XO

121 121 121 121 R248 1 DV33 DV967(1389D) ＢＢＫ

C275 X201 C276
0R(DNS)
C277 XS202 2 RXD
更改 数量 更改单号 签　名 日期
22pF 27MHz 22pF 22pF(DNS) XS04(DNS) 3 TXD 解码 &伺服电原理图
Ｆ 4 GND 设　　计 比例 质量 数量 Ｆ
审　　核 第　２　张 共　５　张 版次： 2.0
标准化 板号： 2967D-1 广东步步高电子工业有限公司ＡＶ厂
批　　准
１ ２ ３ ４ ５ ６
 １ ２ ３ ４ ５ ６

HSYNC 1 2
U206 VSYNC 2 C A5V A5V
SDRAM 64Mb(TSOP54) ASPDIF 13 12 11 10 IEC60958 3
VCC 4 1 B E 3
MA0 23 2 DQ7 R249 R251 R233 G/Y/SY 5
A0 DQ0 0R 0R 75R 2N3906 VD210
MA1 24 4 DQ6 U205F U205E 6 Ａ
A1 DQ1 R209 R269 1N4148
MA2 25 5 DQ5 HCU04 HCU04 B/U/SC 7
Ａ A2 DQ2 2967D-0: PIN5 接R/V/SY（PIN9 ） 0R 75R/1%(DNS)
MA3 26 7 DQ4 8 CVBS
A3 DQ3 R250 2967D-1: PIN5 接G/Y/SY（PIN11 ）
MA4 29 8 DQ3 R/V/SY 9
A4 DQ4 L235 L210
MA5 30 10 DQ2 0R(DNS) 10 0R 1.8uH
A5 DQ5 VD211
MA6 31 11 DQ1 G/Y/SY 11 Y3
A6 DQ6 Q213 1N4148
MA7 32 13 DQ0 R282 12
A7 DQ7 U214 0R(DNS) 3906-S(DNS)
MA8 33 42 DQ15 FS0 B/U/SC 13
A8 DQ8 8/16Mb_FLASH(TSOP48) R217 C253 C254
MA9 34 44 DQ14 14
A9 DQ9 XS204 75R/1% 47pF 47pF
MA10 22 45 DQ13 VD A16 1 48 A17 R234 CVBS 15
A10/AP DQ10 A15 A16 150R
MA11 35 47 DQ12 A15 2 47 FS1 16 XS28 150R/1%(NC)
A11 DQ11 A14 BYTE
DBA0 20 48 DQ11 A14 3 46 GND Lt 17
BA0/A13 DQ12 A13 Vss
DBA1 21 50 DQ10 A13 4 45 A0 18 VGND

4.7K
4.7K
4.7K
BA1/A12 DQ13 A12 D15/A-1

0R A20
51 DQ9 A12 5 44 AD7 Rt 19
DQ14 A11 D7
SDCLK 38 53 DQ8 A11 6 43 20 A5V A5V
CLK DQ15 A10 D14 R235
SDCKE 37 A10 7 42 AD6 C231 SL 21
CKE A9 D6 0R(DNS) 此输出暂时未用到, 但PCB有位号
SD33 A9 8 41 102 22

16Mb FLASH
A8 D13
DCS# 19 1 9 40 AD5 SR 23 VD212
/CS VCC A19 D5

R203
DRAS# 18 14 10 39 24 R270 1N4148(NC)

R238
R239
R240
/RAS VCC A20 D12 R210
DCAS# 17 27 PWR# 11 38 AD4 Cc 25 0R(NC) 75R/1%(DNS)
/CAS VCC WE D4
Ｂ DWE# 16
/WE
URST# 12
RESET Vcc
37 VD
R236
AGND 26 CVBS-ST
SD33 VP 13 36 0R(DNS) SUB 27
VPP D11 L236 L211
DQM0 15 3 UNLOCK 14 35 AD3 +12V 28 0R(NC) 1.8uH(NC)
DQML VCCQ WP/ACC D3 VD213
DQM1 39 9 15 34 Y3 Q214
DQMH VCCQ RY/BY D10 1N4148(NC)
43 A19 16 33 AD2 3906-S(DNS)
VCCQ A18 D2
36 49 A18 17 32 VGND AGND
NC VCCQ A17 D9
40 R241 A8 18 31 AD1 R218 C255 C256
NC A7 D1 R237
6 4.7K(DNS) A7 19 30 75R/1%(NC) 47pF(NC) 47pF(NC)
VSSQ A6 D8 0R
54 12 A6 20 29 AD0 150R/1%(NC)
VSS VSSQ A5 D0
41 46 A5 21 28 PRD#
VSS VSSQ A4 OE
28 52 A4 22 27 GND VGND
VSS VSSQ A3 Vss AGND
A3 23 26 PCE#
A2 CE
A2 24 25 A1 A5V A5V
A1 A0

VD214
U203 R271
U204 R211 1N4148
SDRAM 1Mb*16(SOP50) 0R 75R/1%(DNS)
SDRAM 1Mb*16(SOP50)
G/Y/SY Ｃ

A12
A15
A16
A18
VD
PWR#
A17
Ｃ MA0 21
A0 DQ0
2 DQ7 MA0 21
A0 DQ0
2 DQ0
L237 L212
MA1 22 3 DQ6 MA1 22 3 DQ1
A1 DQ1 A1 DQ1 0R 1.8uH
MA2 23 5 DQ5 MA2 23 5 DQ2 Y4 VD215
A2 DQ2 A2 DQ2 Q215
MA3 24 6 DQ4 MA3 24 6 DQ3 1N4148

4
3
2
1
32
31
30
A3 DQ3 A3 DQ3 3906-S(DNS)
MA4 27 8 DQ3 MA4 27 8 DQ4
A4 DQ4 A4 DQ4
MA5 28 9 DQ2 MA5 28 9 DQ5 U212 R219 C257 C258
A5 DQ5 A5 DQ5
MA6 29 11 DQ1 MA6 29 11 DQ6 75R/1% 47pF 47pF
A6 DQ6 A6 DQ6

WE
MA7 30 12 DQ0 MA7 30 12 DQ7 150R/1%(NC)

A12
A15
A16
A18
A17

VCC
A7 DQ7 A7 DQ7
MA8 31 39 DQ15 MA8 31 39 DQ8 A7 5 29 A14
A8 DQ8 A8 DQ8 A7 A14
MA9 32 40 DQ14 MA9 32 40 DQ9 A6 6 28 A13 VGND
A9 DQ9 A9 DQ9 A6 A13
MA10 20 42 DQ13 MA10 20 42 DQ10 A5 7 27 A8
A10 DQ10 A10 DQ10 A5 A8
DBA0 19 43 DQ12 DBA0 19 43 DQ11 A4 8 26 A9 A5V A5V
BA/A11 DQ11 BA/A11 DQ11 A4 A9
45 DQ11 45 DQ12 A3 9 25 A11
DQ12 DQ12 A3 A11
SDCLK 35 46 DQ10 SDCLK 35 46 DQ13 A2 10 24 PRD#
CLK DQ13 CLK DQ13 A2 OE
48 DQ9 48 DQ14 A1 11 23 A10

1
DQ14 DQ14 A1 A10 VD216

29
SDCKE 34 49 DQ8 SDCKE 34 49 DQ15 A0 12 22 PCE#
CKE DQ15 CKE DQ15 A0 CE R212 R272 1N4148
SD33 SD33 AD0 13 21 AD7
C297 DQ0 DQ7 0R 75R/1%(DNS)
DCS# 18 1 DBA1 18 1 B/U/SC
CS VCC 27pF CS VCC
25 25 Ｄ

DQ1
DQ2
VSS
DQ3
DQ4
DQ5
DQ6
VCC VCC L238 L213

2
Ｄ DRAS# 17 DRAS# 17
RAS RAS 0R 1.8uH
7 7 FLASH/4M Y5 Q216 VD217
VCCQ VCCQ 1N4148
DCAS# 16 13 DCAS# 16 13 3906-S(DNS)

14
15
16
17
18
19
CAS VCCQ CAS VCCQ 20
38 38
VCCQ VCCQ R220 C259 C260
DWE# 15 44 DWE# 15 44
WE VCCQ WE VCCQ 75R/1% 47pF 47pF
DQM0 14 4 DQM0 14 4 150R/1%(NC)
DQML VSSQ DQML VSSQ

AD1
AD2
GND
AD3
AD4
AD5
AD6

10 10
VSSQ VSSQ
DQM1 36 41 DQM1 36 41 VGND
DQMH VSSQ DQMH VSSQ
47 47
VSSQ VSSQ
33 33
NC NC
37 26 37 26 A5V A5V
NC VSS NC VSS
50 50
VSS VSS

VD218
R213 R273 1N4148
0R 75R/1%(DNS)
VGND AGND R/V/SY
L239 L214
Ｅ
Ｅ A11 1
A11 OE
32 PRD# 0R 1.8uH
A9 2 31 A10 Y6 VD219
A9 A10 Q217 1N4148
A8 3 30 PCE#
A8 CE 3906-S(DNS)
A13 4 29 AD7
A13 DQ7 R221 C261 C262
A14 5 28 AD6
A14 DQ6 75R/1% 47pF 47pF
A17 6 27 AD5
A17 DQ5
PWR# 7 26 AD4 150R/1%(NC)
WE DQ4
VD 8 U211 25 AD3
Vcc DQ3
A18 9 24 GND VGND
A18 Vss
A16 10 23 AD2
A16 4Mb FLASH(TSOP32) DQ2
A15 11 22 AD1
A15 DQ1
A12 12 21 AD0
A12 DQ0
A7 13 20 A0
A7 A0
A6 14 19 A1
A6 A1
A5 15 18 A2
A5 A2
A4 16 17 A3
A4 A3

更改 数量 更改单号 签　名 日期 DV967(1389D) ＢＢＫ

只考虑4M/8M/16MFLASH的封装，32M不考虑 设　　计 比例 质量 数量 Ｆ
Ｆ
4M: A0 ~ A18 8M: A0 ~ A19 16M: A0 ~ A20
解码 &伺服电原理图
审　　核 第　３　张 共　５　张 版次：2.0
标准化
板号： 2967D-1 广东步步高电子工业有限公司ＡＶ厂
批　　准
１ ２ ３ ４ ５ ６
 １ ２ ３ ４ ５ ６

OKA VCC DV33

R225 R226
+12V -12V C2116 R228 VCC
0R(DNS) 0R 4.7R
102
TC215 TC216 AGND
U207 C291 TC236 Ａ
Ａ C278 C279 C280 100uF/25V C281 C282 C283 CS4360 104 220uF/10V
100uF/25V
104 104 104 104 104 104 R2132 C293 TC231 C292
R2129 24K 20K
104 100uF/10V 104 1 28 MUTE1
VLS MUTEC1
AGND AGND SDAT0 2 27 LL
SDIN1 AOUTA1
C2111 101 SDAT1 3 26 RR

8
SDIN2 AOUTB1
SDAT2 4 25 MUTE2
TC240 +12V SDIN3 MUTEC2
SBCLK 5 24 LS
10uF/16V R2130 R2131 R2136 6.8K SCLK AOUTA2
2 SLRCK 6 23 RS
LRCK AOUTB2
CH-R 1 4.7K 4.7K SACLK 7 22
MCLK VA
3 8 21
VD GND
C2112 C2122 9 20 CENT
U219A GND AOUTA3
102 122 RST# 10 19 LFE
-12V 4580 RST AOUTB3

4
SCL 11 18 MUTE3
SCL MUTEC3
SDA 12 17
R2156 SDA VQ
AGND 13 16
R2133 24K 20K CS FILT+
14 15
VLC M2 C290 TC233
C2114 101 104 10uF/16V Ｂ

8
R2117 1K R280
Ｂ Rt
TC241 +12V 0R(DNS)
10uF/16V R2134 R2135 R2148 6.8K C289 TC232
6
104 10uF/16V

AL
AR
CH-L 7 4.7K 4.7K
R2111 R2118 1K 5 R279
100K C2115 C2129
U219B 0R
102 122 AGND
Q205 -12V 4580 R275 R276

4
2SC1815Y-S 1K(DNS) 1K(DNS)
AGND
AGND AGND
R2112 R2119 1K R2137 24K RR
R
100K
TC225 10uF/16V
Q206 C2117 101

8
L LL
2SC1815Y-S R2120 1K TC221 +12V
Lt 10uF/16V
10uF/16V R2138 R2139 R2152 6.8K TC226
2
R2121 1K
SR CH-SR 1 4.7K 4.7K R277 R278
3 180K(DNS)
180K(DNS)使用AL、AR时有效
C2118 C2130
Ｃ R2113 R2122 1K U220A
102 122
Ｃ
-12V 4580

4
100K C2132 683(DNS)
AGND AGND
Q207
SR# RS
2SC1815Y-S R2141 24K

30
TC227 10uF/16V
AGND
R2123 1K
MUTE-OUT C2119 0R
R2114 C2120 101

8
100K C2131 0R
Q208 TC222 +12V
2SC1815Y-S R2124 1K 10uF/16V R2142 R2143 R2153 6.8K
SL 6 SL# LS
CH-SL 7 4.7K 4.7K 10uF/16V
TC228
5
SUB R2125 1K C2121 C2133 C2138 683(DNS)
U220B
102 122
-12V 4580

4
R2115 R2126 1K SW LFE
100K R2145 24K AGND
TC229 10uF/16V
Q209
C2123 101 C2134 683(DNS)
Ｄ
Ｄ

8
2SC1815Y-S
TC223 +12V
AGND /C CENT
R2127 1K 10uF/16V R2146 R2147 R2154 6.8K
2 10uF/16V
R2116 TC230
CH-SW 1 4.7K 4.7K
100K 3 C2128 0R
Q210
C2124 C2135
2SC1815Y-S R2128 1K U221A R2107 0R(DNS)
Cc 102 122 MIC-DET
-12V 4580

4
+12V VCC
Q218
AGND
R2149 24K R2103 1K 2SA1015Y-S
VCC MUTE-OUT
+12V
VD207
R2161
C2126 101 1N4148

8
0R
MUTE1 VD206 R2160
TC224 +12V Q219
1N4148 0R(DNS)
10uF/16V R2150 R2151 R2155 6.8K R2101 TC238 2SA1015Y-S
6 VD208
R2102 100K 47uF/10V R2104 3.3K
CH-C 7 4.7K 4.7K 1N4148 10K Q212 VD205
5 MUTE2 2SC1815Y-S 1N4148 TC235
Ｅ
Ｅ C2127 C2136
U221B 102 122 R2106 220uF/16V
VD209
-12V Q211 10K

4
4580 1N4148
2SA1015Y-S
MUTE3 AGND AGND
使用内置MICROPHONE功能时选装此功能
DV33 AGND

U210 OKA R2108 R2109

10K
C287 CS5333(16)(NC) DV33 MUTE-DAC -12V 10K
104(NC)
R258 R2159
1 16 RST# 使用AL、AR时有效
R208 VL RST 150R(NC) 1K(DNS)
SACLK 2 15
47K(DNS) MCLK VQ
SBCLK 3 14 C285 105(NC) R232 R257
SCLK AINL
MCDATA 4 13 0R(DNS) 0R(NC)
SDATA AINR
5 12 C286 105(NC)
VA REF_G
6 11
GND FILT+
7 10
R207 LRCK TST TC242 C288
8 9
47K(NC) DIN DIF 10uF/16V(NC) 102(NC)
C284 TC244 DV967(1389D) ＢＢＫ
104(NC)
10uF/16V(NC) R256
更改 数量 更改单号 签　名 日期
SDATA: 47K 接地：slave mode TC243 R231
10uF/16V(NC) 0R(DNS) 设　　计 比例 质量 数量 Ｆ
Ｆ 接VL: master mode 0R(NC)
SLRCK 解码 &伺服电原理图
审　　核 第　４　张 共　５　张 版次：2.0
标准化
板号： 2967D-1 广东步步高电子工业有限公司ＡＶ厂
批　　准
１ ２ ３ ４ ５ ６
31
DV113S MATERIAL LIST
1. POWER BOARD
MATERIAL CODE MATERIAL NAME SPECIFICATIONS UNIT QUANTITY LOCATION
294 CARBON FILM RESISTOR 1/4W10K±5% SHAPED 10 PCS 1 R507
0010064 METAL FILM RESISTOR 1/4W10K±1% SHAPED 10 PCS 1 R509
0000461 CARBON FILM RESISTOR 1/4W9.1K±5% SHAPED 10 PCS 1 R512
0010256 METAL FILM RESISTOR 1/4W3.6K±1% SHAPED 10 PCS 1 R508
0000431 CARBON FILM RESISTOR 1/4W75Ω±5% SHAPED 10 PCS 1 R505
METAL OXIDE FILM
10135 2W39K±5% SHAPED FLAT 15×9 PCS 1 R503
RESISTOR
0000278 CARBON FILM RESISTOR 1/4W330Ω±5% SHAPED 10 PCS 1 R517
0000380 CARBON FILM RESISTOR 1/4W510Ω±5% SHAPED 10 PCS 1 R506
HIGH VOLTAGE
0070001 1/2W680K±5% PCS 1 R501
RESISTOR
VOLTAGE REGULATOR
0580054 9.1V 1W PCS 1 ZD502
DIODE
METAL OXIDE FILM
10250 1W22Ω±5％ SHAPED R 15×8 PCS 1 R511
RESISTOR
0570005 DIODE 1N4007 PCS 4 D501~D504
0570011 DIODE RL202 PCS 2 D509,D513
0200138 PORCELAIN CAPACITOR 50V 104 ±20% 5mm PCS 4 C504,C508,C510,C515
0200224 PORCELAIN CAPACITOR 1000V 103 +80%-20% 7.5mm PCS 1 C502
0200223 PORCELAIN CAPACITOR 1000V 101 +80%-20% 7.5mm PCS 1 C503
0200228 PORCELAIN CAPACITOR 1000V 101 ±10% 7.5mm PCS 1 C503
210191 TERYLENE CAPACITOR 50V 222 ±10% 5mm PCS 1 C506
0260559 CD CD11T 50V47U±20%6×12 2.5 PCS 2 TC502,TC512
0260563 CD KM 400V47U±20%18×20 7.5 PCS 1 TC501
260557 CD CD11T 16V100U±20%6×12 2.5 PCS 1 TC513
0260594 CD CD11T 25V220U±20%8×12 3.5 PCS 2 TC503,TC504
0260560 CD CD11T 10V1000U±20%8×16 3.5 PCS 3 TC505,TC506,TC510
MAGNETIC BEADS
0390057 RH354708 PCS 1 L503
INDUCTOR
0410010 CHOKE COIL VERTICAL 10UH 1A 5mm PCS 1 L505
0410011 CHOKE COIL VERTICAL 10UH 2A 5mm PCS 1 L507
PHOTOELECTRIC
1080011 HS817 PCS 1 U502
COUPLER
0570013 DIODE HER105 PCS 3 D506,D508,D511
570014 DIODE HER107 PCS 1 D505
0680010 SCHOTTKY DIODE SR560 DO-27 PCS 1 D510
0880553 IC LM431ACZ TO-92 PCS 1 U503
0880581 IC TL431C TO-226AA(LP) PCS 1 U503
0880800 IC 431L TO-92 PCS 1 U503
0210066 TERYLENE CAPACITOR 275V 104 ±20% 15mm PCS 1 BC501
0210070 TERYLENE CAPACITOR 275V 104 ±10% 15mm PCS 1 BC501
200267 CERAMIC CAPACITOR CT81 250VAC221±20% 10mm PCS 1 BC503
0200268 CERAMIC CAPACITOR CT81 250VAC221±10% 10mm PCS 1 BC503
SWITCHING POWER
0460394 BCK-19-0179 PCS 1 T501
TRANSFORMER
1000004 POWER GRID FILTER UT-20 40mH ±20% 10×13 PCS 1 L501
1563407 PCB 5501A-4 PCS 1
2100003 CONNECTION CORDS Φ0.6 SHAPED 7.5mm PCS 2 JP501,JP503
2100010 CONNECTION CORDS Φ0.6 SHAPED 5mm PCS 1 JP502
2300021 FUSE T1.6AL 250V PCS 1 F501
1940045 SOCKET 2P 8.0mm 2# PCS 2 BCN501,BCN502
1940023 SOCKET 7P 2.0mm PCS 1 CN502
1940027 SOCKET 2P 2.0mm PCS 1 CN501
0881933 IC VIPER22A DIP8 PCS 1 U501
GROUND CHIP OF
3870115 AB903 PCS 2 G501,G502
POWER BOARD

2. MAIN PANEL
MATERIAL CODE MATERIAL NAME SPECIFICATIONS UNIT QUANTITY LOCATION
5232805 SOFT SPONGE SPACER 6×6×2.5 DOUBLE-FACED HARD PCS 1 1PC FOR IR SENSOR
9 CARBON FILM RESISTOR 1/6W100Ω±5% PCS 1 R415
0090023 SMD RESISTOR 1/16W 10K ±5% PCS 3 R416,R417,R418
0570006 DIODE 1N4148 PCS 1 D401
LIGHT TOUCH RESTORE
1340003 HORIZONTAL 6×6×1 PCS 3 K401~K403
SWITCH
0200139 PORCELAIN CAPACITOR 50V 104 +80%-20% 5mm PCS 1 C405
0260206 CD CD11C 10V100U±20%5×7 2 PCS 1 TC407
2360002 IR SENSOR HS0038B PCS 1 U403
32
 2100010 CONNECTION CORDS Φ0.6 SHAPED 5mm PCS 1 JP401
6P170 2.0 2PLUG WITH L
2121370 FLAT CABLE PCS 1 XS401
NEEDLE REVERSE
1563482 PCB 4911S-1 PCS 1

3. AV BOARD
MATERIAL CODE MATERIAL NAME SPECIFICATIONS UNIT QUANTITY LOCATION
362 CARBON FILM RESISTOR 1/4W220Ω±5% SHAPED 10 PCS 1 R701
0000123 CARBON FILM RESISTOR 1/6W330Ω±5% SHAPED 7.5 PCS 1 R709
0090005 SMD RESISTOR 1/16W 33Ω ±5% 0603 PCS 1 R708
0090181 SMD RESISTOR 1/16W 100Ω ±5% 0603 PCS 1 R702
0090002 SMD RESISTOR 1/16W 2.2Ω ±5% 0603 PCS 1 R706
0090019 SMD RESISTOR 1/16W 4.7K ±5% 0603 PCS 1 R704
0000129 CARBON FILM RESISTOR 1/6W1K±5% SHAPED 7.5 PCS 1 R711
0090017 SMD RESISTOR 1/16W 2.2K ±5% 0603 PCS 2 R710,R712
0090006 SMD RESISTOR 1/16W 75Ω ±5% 0603 PCS 1 R705
310066 SMD CAPACITOR 50V 102 ±10% 0603 PCS 2 C705,C706
0310207 SMD CAPACITOR 50V 104 ±20% X7R 0603 PCS 3 C707,C710,C716
0310543 SMD CAPACITOR 50V 104 ±10% X7R 0603 PCS 3 C707,C710,C716
0310222 SMD CAPACITOR 25V 104 ±20% X7R 0603 PCS 3 C707,C710,C716
0090001 SMD RESISTOR 1/16W 0Ω ±5% 0603 PCS 6 R717~R721,R707
780050 TRIODE S8050D PCS 3 V701~V703
MAGNETIC BEADS
390057 RH354708 PCS 10 L705~L714
INDUCTOR
1910140 TERMINAL SOCKET AV4-8.4-5G-5 BLACK PCS 1 JK701
SA-001-012 BLACK IRON PIECE
1910129 TERMINAL SOCKET PCS 1 JK703
SCREEN-SHIELDED
14P 1.0mm STRAIGHT DUAL
1940140 CABLE SOCKET PCS 1 XS701
LINE PLUG
2100010 CONNECTION CORDS Φ0.6 SHAPED 5mm PCS 3 JP704,JP710,JP711
2100003 CONNECTION CORDS Φ0.6 SHAPED 7.5mm PCS 5 JP705~JP709
2100004 CONNECTION CORDS Φ0.6 SHAPED 10mm PCS 3 JP701~JP703
1860029 SCART SOCKET SCART-01 PCS 1 JK706
1563648 PCB 7112S-0 PCS 1

4. OKV BOARD
MATERIAL CODE MATERIAL NAME SPECIFICATIONS UNIT QUANTITY LOCATION
0000126 CARBON FILM RESISTOR 1/6W560Ω±5% SHAPED 7.5 PCS 1 R603
0000129 CARBON FILM RESISTOR 1/6W1K±5% SHAPED 7.5 PCS 1 R607
90014 SMD RESISTOR 1/16W 1K ±5% 0603 PCS 2 R619,R626
0090026 SMD RESISTOR 1/16W 22K ±5% 0603 PCS 1 R601
0090019 SMD RESISTOR 1/16W 4.7K ±5% 0603 PCS 3 R622,R628,R623
0090020 SMD RESISTOR 1/16W 5.1K ±5% 0603 PCS 1 R616
R605,R617,R620,R621,R62
0090023 SMD RESISTOR 1/16W 10K ±5% 0603 PCS 5
4
137 CARBON FILM RESISTOR 1/6W10K±5% SHAPED 7.5 PCS 1 R612
MAGNETIC BEADS
0390057 RH354708 PCS 1 L602
INDUCTOR
0000118 CARBON FILM RESISTOR 1/6W10Ω±5% SHAPED 7.5 PCS 2 R632,R633
0090024 SMD RESISTOR 1/16W 15K ±5% 0603 PCS 1 R618
0000338 CARBON FILM RESISTOR 1/6W15K±5% SHAPED 7.5 PCS 1 R614
90188 SMD RESISTOR 1/16W 18K ±5% 0603 PCS 1 R615
0000144 CARBON FILM RESISTOR 1/6W47K±5% SHAPED 7.5 PCS 1 R610
0090027 SMD RESISTOR 1/16W 27K ±5% 0603 PCS 1 R629
0090028 SMD RESISTOR 1/16W 33K ±5% 0603 PCS 2 R609,R613
0090018 SMD RESISTOR 1/16W 3.3K ±5% 0603 PCS 1 R608
TC601,TC603,TC607,TC61
0260127 CD CD11 16V4.7U±20%5×11 2 PCS 7 0,TC611,
TC613,TC621
260021 CD CD11 16V22U±20%5×11 2 PCS 1 TC605
0260200 CD CD11C 16V47U±20%5×7 2 PCS 2 TC608,TC609
0260040 CD CD11 25V100U±20%6×12 2.5 PCS 2 TC615,TC616
0310047 SMD CAPACITOR 50V 101 ±5% NPO 0603 PCS 3 C605,C607,C620
0310066 SMD CAPACITOR 50V 102 ±10% 0603 PCS 3 C619,C625,C606
0310072 SMD CAPACITOR 50V 103 ±10% 0603 PCS 2 C603,C616
C602,C609,C613,C614,C62
0310084 SMD CAPACITOR 50V 104 +80%-20% 0603 PCS 8
2,C623,C601,C604
C602,C609,C613,C614,C62
0310058 SMD CAPACITOR 25V 104 +80%-20% 0603 PCS 8
2,C623,C601,C604
0310323 SMD CAPACITOR 50V 392 ±10% 0603 PCS 2 C615,C608
 0310197 SMD CAPACITOR 50V 561 ±10% 0603 PCS 2 C610,C612
0390095 SMD MAGNETIC BEADS FCM1608K-221T05 PCS 2 L601,L603
0880124 IC NJM4558D DIP PCS 2 U601,U602
6P200 2.0 2PLUG WITH L
2121509 FLAT CABLE PCS 1 XS601
NEEDLE REVERSE
2100010 CONNECTION CORDS Φ0.6 SHAPED 5mm PCS 2 JP603,JP605
JP601,JP602,JP604,JP606,J
2100003 CONNECTION CORDS Φ0.6 SHAPED 7.5mm PCS 5
P607
1980048 MIC SOCKET ST-403-070-100 PCS 1 MIC602
ROTATED
0160184 WH09JTC1Z11-A10K-F30 PCS 1 VR602
POTENTIOMETER
1563776 PCB 6911S-1 PCS 1
880230 IC PT2399 DIP PCS 1 U603

5. OKV BOARD
MATERIAL CODE MATERIAL NAME SPECIFICATIONS UNIT QUANTITY LOCATION
L235,L237~L239,L310,L31
2,L314,L316,L317,L319,L3
20,R201,R203,R209,R211~
0090001 SMD RESISTOR 1/16W 0Ω ±5% 0603 PCS 35 R213,R222,R226,R236,R24
5,R247,R249,R251,R279,R3
31,R339,R340,R342,R344,R
347,R349,R351,R2161,R282
0090214 SMD RESISTOR 1/16W 2.2MΩ ±5% 0603 PCS 1 R281
0090272 SMD RESISTOR 1/16W1Ω±5% 0603 PCS 5 R304~R307,R321
0090106 SMD RESISTOR 1/16W 4.7Ω ±5% 0603 PCS 4 R206,R228,R301,R302
0090006 SMD RESISTOR 1/16W 75Ω ±5% 0603 PCS 5 R233,R217,R219~R221
R255,R261~R268,R291~R2
0090005 SMD RESISTOR 1/16W 33Ω ±5% 0603 PCS 15
96
0090009 SMD RESISTOR 1/16W 330Ω ±5% 0603 PCS 2 R325,R326
R215,R254,R259,R260,R32
0090014 SMD RESISTOR 1/16W 1K ±5% 0603 PCS 12 3,R324,R2103,R2117~R212
0,R205
0090016 SMD RESISTOR 1/16W 1.5K ±5% 0603 PCS 1 R243
0090249 SMD RESISTOR 1/16W 510Ω ±5% 0603 PCS 1 R214
0090018 SMD RESISTOR 1/16W 3.3K ±5% 0603 PCS 2 R242,R2104
R216,R238~R240,R2130,R2
0090019 SMD RESISTOR 1/16W 4.7K ±5% 0603 PCS 8
131,R2134,R2135
90021 SMD RESISTOR 1/16W 6.8K ±5% 0603 PCS 2 R2136,R2148
R252,R309,R311,R313,R31
4,R328~R330,R332,R333,R
0090023 SMD RESISTOR 1/16W 10K ±5% 0603 PCS 15
2102,R2106,R2108,R2109,R
274
0090024 SMD RESISTOR 1/16W 15K ±5% 0603 PCS 2 R223,R334
0090188 SMD RESISTOR 1/16W 18K ±5% 0603 PCS 1 R335
R312,R315,R316,R336,R21
0090025 SMD RESISTOR 1/16W 20K ±5% 0603 PCS 6
32,R2156
90255 SMD RESISTOR 1/16W24K±5% 0603 PCS 2 R2129,R2133
R224,R246,R308,R310,R21
0090034 SMD RESISTOR 1/16W 100K ±5% 0603 PCS 7
01,R2111~R2112
0090197 SMD RESISTOR 1/16W 150K ±5% 0603 PCS 2 R319,R320
PRECISION SMD
0090231 1/16W 680K ±1% 0603 PCS 2 R317,R318
RESISTOR
PRECISION SMD
0090319 1/16W 750K ±1% 0603 PCS 1 R227
RESISTOR
375 CARBON FILM RESISTOR 1/4W2.2Ω±5% PCS 1 R327
TC201,TC202,TC217,TC22
0260019 CD CD11 16V10U±20%5×11 2 PCS 9 5~TC226,TC232,TC233,TC
240,TC241
TC203~TC206,TC211,TC2
0260009 CD CD11 10V47U±20%5×11 2 PCS 12 37,TC238,TC302~TC304,T
C308,TC309
0260012 CD CD11 10V100U±20%5×11 2 PCS 2 TC214,TC231
0260040 CD CD11 25V100U±20%6×12 2.5 PCS 2 TC215,TC216
TC207~TC209,TC212,TC2
0260013 CD CD11 10V220U±20%6×12 2.5 PCS 8
36,TC245,TC301,TC305
0260028 CD CD11 16V220U±20%6×12 2.5 PCS 1 TC235
0310043 SMD CAPACITOR 50V 22P ±5% NPO 0603 PCS 3 C222,C275,C276
C253,C254,C257,C258,C25
0310045 SMD CAPACITOR 50V 47P ±5% NPO 0603 PCS 8
9~C262
0310047 SMD CAPACITOR 50V 101 ±5% NPO 0603 PCS 2 C2111,C2114
34
0310596 SMD CAPACITOR 50V 121±20% 0603 PCS 4 C263~C266
0310048 SMD CAPACITOR 50V 151 ±5% NPO 0603 PCS 2 C304,C306
0310051 SMD CAPACITOR 50V 331 ±5% NPO 0603 PCS 2 C318,C319
0310052 SMD CAPACITOR 50V 391 ±5% NPO 0603 PCS 1 C233
C223,C231,C272,C2112,C2
0310066 SMD CAPACITOR 50V 102 ±10% 0603 PCS 6
115,C2116
0310231 SMD CAPACITOR 50V 122 ±10% 0603 PCS 2 C2122,C2129
310067 SMD CAPACITOR 50V 152 ±10% 0603 PCS 1 C217
0310068 SMD CAPACITOR 50V 222 ±10% 0603 PCS 3 C221,C307,C310
0310071 SMD CAPACITOR 50V 682 ±10% 0603 PCS 1 C294
0310072 SMD CAPACITOR 50V 103 ±10% 0603 PCS 1 C215
0310201 SMD CAPACITOR 50V 153 ±10% 0603 PCS 1 C316
310055 SMD CAPACITOR 16V 333 ±10% 0603 PCS 1 C225
0310056 SMD CAPACITOR 16V 473 ±10% 0603 PCS 2 C219,C220
C207~C214,C216,C224,C22
6~C230,C234~C252,C268~
C271,C273,C274,C278~C28
0310084 SMD CAPACITOR 50V 104 +80%-20% 0603 PCS 76 3,C289~C293,C295,C296,C
301~C303,C305,C309,C311
~C315,C317,C320,C326~C3
29,C345,C2140~C2145

C207~C214,C216,C224,C22
6~C230,C234~C252,C268~
C271,C273,C274,C278~C28
0310058 SMD CAPACITOR 25V 104 +80%-20% 0603 PCS 76 3,C289~C293,C295,C296,C
301~C303,C305,C309,C311
~C315,C317,C320,C326~C3
29,C345,C2140~C2145
0310234 SMD CAPACITOR 16V 105 +80%-20% 0603 PCS 5 C201~C205
0390044 SMD INDUCTOR 10UH ±10% 2012 PCS 3 L207,L303,L306
0390096 SMD INDUCTOR 1.8UH ±10% 1608 PCS 4 L210, L212~L214
MAGNETIC BEADS L218~L223,L226,L229,L30
0390057 RH354708 PCS 10
INDUCTOR 2,L205
L206,L208,L209,L215,L217
,L227,L228,L230~L234,L30
0390095 SMD MAGNETIC BEADS FCM1608K-221T05 PCS 26 1,L304,L305,L307~L309,L3
11,L318,L321~L324,R229,L
313
VD201,VD205~VD211,VD2
0700007 SMD DIODE 1N4148 PCS 14
14~VD219
VD201,VD205~VD211,VD2
0700001 SMD DIODE LS4148 PCS 14
14~VD219
VD201,VD205~VD211,VD2
0700002 SMD DIODE LL4148 PCS 14
14~VD219
0780050 TRIODE S8050D PCS 2 V307,V308
0780049 TRIODE S8550D PCS 2 V306,V309
0780063 SMD TRIODE 9015C PCS 1 Q204
0780197 SMD TRIODE C1815 PCS 3 Q205~Q206,Q212
0780198 SMD TRIODE 2SA1015 PCS 3 Q211,Q218,Q219
0780040 SMD TRIODE 3904 SOT-23 PCS 2 V305,V310
0780193 SMD TRIODE 2SK3018 PCS 2 V303,V304
0780115 SMD TRIODE 2SB1132 PCS 2 V301,V302
880185 IC NJM4558M SOP PCS 1 U219
0880562 IC 4580 SOP PCS 1 U219
0880361 IC 4558 SOP PCS 1 U219
0880322 IC MM74HCU04M SOP PCS 1 U205
0880513 IC HCU04 SOP PCS 1 U205
882104 IC HY57V161610ET-7 TSOP PCS 2 U203,U204
0881275 IC IC42S16100-7T SOP PCS 2 U203,U204
0881182 IC LM1117MP-ADJ SOT-223 PCS 1 U209
0881057 IC CS4360 SSOP PCS 1 U207
0881031 IC 24C02N SOP PCS 1 U202
0882293 IC MT1389XE(D VERSION) QFP PCS 1 U201
0881378 IC BA5954FP HSOP PCS 1 U302
0960020 CRYSTAL OSCILLATOR 27.00MHz 49-S PCS 1 X201
14P 1.0mm STRAIGHT DUAL
1940140 CABLE SOCKET PCS 1 XS204
LINE PLUG
1632274 PCB 2967D-5 PCS 1
1940007 SOCKET 7P 2.5mm PCS 1 XS203
1940094 CABLE SOCKET 24P 0.5mm SMD WITH CLASP PCS 1 XS301

35
1940024 SOCKET 5P 2.0mm PCS 1 XS302
1940005 SOCKET 6P 2.0mm PCS 3 XS303,XS201,XS304

36