05−392

DIAGNOSTICS − SFI SYSTEM (3MZ−FE)

05284−28

DIAGNOSTIC TROUBLE CODE CHART

HINT:
Parameters listed in the chart may be different than your readings depending on the type of instrument used
and other factors.
During the DTC check, refer to the table below if a malfunction code is displayed. For details about each
code, refer to the page number in the DTC Chart’s left column.
DTC No.
Detection Item Trouble Area MIL*1 Memory
(See Page)
S Open or short in OCV (bank 1) circuit
P0010 Camshaft Position ”A” Actuator
S OCV (bank 1) f f
(05−402) Circuit (Bank 1)
S ECM
S Valve timing
Camshaft Position ”A” −Timing
P0011 S OCV (bank 1)
Over−Advanced or System Per- f f
(05−408) S Camshaft timing gear assy
formance (Bank 1)
S ECM
P0012 Camshaft Position ”A” −Timing
S Same as DTC No. P0011 f f
(05−408) Over− Retarded (Bank 1)
Crankshaft Position − Camshaft S Mechanical system (Timing belt has jumped tooth, belt
P0016
Position Correlation (Bank 1 stretched) f f
(05−416)
Sensor A) S ECM
Crankshaft Position − Camshaft
P0018
Position Correlation (Bank 2 S Same as DTC No. P0016 f f
(05−416)
Sensor A)
S Open or short in OCV (bank 2) circuit
P0020 Camshaft Position ”A” Actuator
S OCV (bank 2) f f
(05−402) Circuit (Bank 2)
S ECM
S Valve timing
Camshaft Position ”A” −Timing
P0021 S OCV (bank 2)
Over−Advanced or System Per- f f
(05−408) S Camshaft timing gear assy
formance (Bank 2)
S ECM
P0022 Camshaft Position ”A” −Timing
S Same as DTC No. P0021 f f
(05−408) Over− Retarded (Bank 2)
S Open or short in heater circuit of A/F sensor
Oxygen (A/F) Sensor Heater
P0031*3 S A/F sensor heater (bank 1 sensor 1)
Control Circuit Low (Bank 1 Sen- f f
(05−418) S A/F relay
sor 1)
S ECM
S Short in heater circuit of A/F sensor
Oxygen (A/F) Sensor Heater
P0032*3 S A/F sensor heater (bank 1 sensor 1)
Control Circuit High (Bank 1 f f
(05−418) S A/F relay
Sensor 1)
S ECM
S Open or short in heater circuit of heated oxygen sensor
P0037 Oxygen Sensor Heater Control S Heated oxygen sensor heater (bank 1 sensor 2)
f f
(05−423) Circuit Low (Bank 1 Sensor 2) S EFI relay
S ECM
S Short in heater circuit of heated oxygen sensor
P0038 Oxygen Sensor Heater Control S Heated oxygen sensor heater (bank 1 sensor 2)
f f
(05−423) Circuit High (Bank 1 Sensor 2) S EFI relay
S ECM
S Open or short in heater circuit of A/F sensor
Oxygen (A/F) Sensor Heater
P0051*3 S A/F sensor heater (bank 2 sensor 1)
Control Circuit Low (Bank 2 Sen- f f
(05−418) S A/F relay
sor 1)
S ECM
S Short in heater circuit of A/F sensor
Oxygen (A/F) Sensor Heater
P0052*3 S A/F sensor heater (bank 2 sensor 1)
Control Circuit High (Bank 2 f f
(05−418) S A/F relay
Sensor 1)
S ECM

2004 HIGHLANDER REPAIR MANUAL (RM1086U)

 05−393
DIAGNOSTICS − SFI SYSTEM (3MZ−FE)

DTC No.
Detection Item Trouble Area MIL*1 Memory
(See Page)
S Open or short in heater circuit of heated oxygen sensor
P0057 Oxygen Sensor Heater Control S Heated oxygen sensor heater (bank 2 sensor 2)
f f
(05−423) Circuit Low (Bank 2 Sensor 2) S EFI relay
S ECM
S Short in heater circuit of heated oxygen sensor
P0058 Oxygen Sensor Heater Control S Heated oxygen sensor heater (bank 2 sensor 2)
f f
(05−423) Circuit High (Bank 2 Sensor 2) S EFI relay
S ECM
S Open or short in MAF meter circuit
P0100
Mass or volume Air Flow Circuit S MAF meter f f
(05−428)
S ECM
P0101 Mass or volume Air Flow Circuit
S MAF meter f f
(05−435) Range/Performance Problem
S Open in MAF meter circuit
P0102 Mass or volume Air Flow Circuit S Short in ground circuit
f f
(05−428) Low Input S MAF meter
S ECM
S Short in MAF meter circuit (to +B circuit)
P0103 Mass or volume Air Flow Circuit
S MAF meter f f
(05−428) High Input
S ECM
S Open or short in IAT sensor circuit
P0110
Intake Air Temperature Circuit S IAT sensor (built in MAF meter) f f
(05−437)
S ECM
S Short in IAT sensor circuit
P0112 Intake Air Temperature Circuit
S IAT sensor (built in MAF meter) f f
(05−437) Low Input
S ECM
S Open in IAT sensor circuit
P0113 Intake Air Temperature Circuit
S IAT sensor (built in MAF meter) f f
(05−437) High Input
S ECM
S Open or short ECT sensor circuit
P0115 Engine Coolant Temperature Cir-
S ECT sensor f f
(05−442) cuit
S ECM
Engine Coolant Temperature Cir-
P0116
cuit Range/Performance Prob- S ECT sensor f f
(05−447)
lem
S Short in ECT sensor circuit
P0117 Engine Coolant Temperature Cir-
S ECT sensor f f
(05−442) cuit Low Input
S ECM
S Open in ECT sensor circuit
P0118 Engine Coolant Temperature Cir-
S ECT sensor f f
(05−442) cuit High Input
S ECM
P0120 Throttle/Pedal Position Sensor/ S Throttle position sensor (built in throttle body)
f f
(05−449) Switch ”A” Circuit S ECM
Throttle/Pedal Position Sensor/
P0121
Switch ”A” Circuit Range/Perfor- S Throttle position sensor (built in throttle body) f f
(05−458)
mance Problem
S Throttle position sensor (built in throttle body)
P0122 Throttle/Pedal Position Sensor/ S Short in VTA1 circuit
f f
(05−449) Switch ”A” Circuit Low Input S Open in VC circuit
S ECM
S Throttle position sensor (built in throttle body)
S Open in VTA1 circuit
P0123 Throttle/Pedal Position Sensor/
S Open in E2 circuit f f
(05−449) Switch ”A” Circuit High Input
S VC and VTA1 circuit are short circuited
S ECM

2004 HIGHLANDER REPAIR MANUAL (RM1086U)

05−394
DIAGNOSTICS − SFI SYSTEM (3MZ−FE)

DTC No.
Detection Item Trouble Area MIL*1 Memory
(See Page)
S Cooling system
P0125 Insufficient Coolant Temperature
S ECT sensor f f
(05−460) for Closed Loop Fuel Control
S Thermostat
S Thermostat (water inlet)
Coolant Thermostat (Coolant
P0128 S Cooling system
Temperature Below Thermostat f f
(05−462) S ECT sensor
Regulating Temperature)
S ECM
S Open or short in heated oxygen sensor circuit
P0136 Oxygen Sensor Circuit Malfunc- S Heated oxygen sensor
f f
(05−465) tion (Bank 1 Sensor 2) S Heated oxygen sensor heater
S EFI relay
P0156 Oxygen Sensor Circuit Malfunc-
S Same as DTC No. P0136 f f
(05−465) tion (Bank 2 Sensor 2)
S Air induction system
S Injector blockage
S MAF meter
S ECT sensor
S Fuel pressure
P0171 S Gas leakage in exhaust system
System too Lean (Bank 1) f f
(05−477) S Open or short in A/F sensor (bank 1 sensor 1) circuit
S A/F sensor (bank 1 sensor 1)
S A/F sensor heater (bank 1 sensor 1)
S A/F relay
S PCV valve and hose
S PCV hose connection
S Injector leak, blockage
S MAF meter
S ECT sensor
S Ignition system
P0172 S Fuel pressure
System too Rich (Bank 1) f f
(05−477) S Gas leakage in exhaust system
S Open or short in A/F sensor (bank 1 sensor 1) circuit
S A/F sensor (bank 1 sensor 1)
S A/F sensor heater (bank 1 sensor 1)
S A/F relay
S Air induction system
S Injector blockage
S MAF meter
S ECT sensor
S Fuel pressure
P0174 S Gas leakage in exhaust system
System too Lean (Bank 2) f f
(05−477) S Open or short in A/F sensor (bank 2 sensor 1) circuit
S A/F sensor (bank 2 sensor 1)
S A/F sensor heater (bank 2 sensor 1)
S A/F relay
S PCV valve and hose
S PCV hose connection
S Injector leak, blockage
S MAF meter
S ECT sensor
S Ignition system
P0175 S Fuel pressure
System too Rich (Bank 2) f f
(05−477) S Gas leakage in exhaust system
S Open or short in A/F sensor (bank 2 sensor 1) circuit
S A/F sensor (bank 2 sensor 1)
S A/F sensor heater (bank 2 sensor 1)
S A/F relay
P0220 Throttle/Pedal Position Sensor/
S Same as DTC No. P0120 f f
(05−449) Switch ”B” Circuit

2004 HIGHLANDER REPAIR MANUAL (RM1086U)

 05−395
DIAGNOSTICS − SFI SYSTEM (3MZ−FE)

DTC No.
Detection Item Trouble Area MIL*1 Memory
(See Page)
S Throttle position sensor (built in throttle body)
P0222 Throttle/Pedal Position Sensor/ S Short in VTA2 circuit
f f
(05−449) Switch ”B” Circuit Low Input S Open in VC circuit
S ECM
S Throttle position sensor (built in throttle body)
S Open in VTA2 circuit
P0223 Throttle/Pedal Position Sensor/
S Open in E2 circuit f f
(05−449) Switch ”B” Circuit High Input
S VC and VTA2 circuit are short circuited
S ECM
S Open or short in engine wire
S Connector connection
S Vacuum hose connection
S Ignition system
S Injector
S Fuel pressure
P0300 Random/Multiple CylinderMisfire S MAF meter
f*2 f
(05−490) Detected S ECT sensor
S Compression pressure
S Valve clearance
S Valve timing
S PCV hose connection
S PCV hose
S ECM
P0301
Cylinder 1 Misfire Detected S Same as DTC No. P0300 f*2 f
(05−490)
P0302
Cylinder 2 Misfire Detected S Same as DTC No. P0300 f*2 f
(05−490)
P0303
Cylinder 3 Misfire Detected S Same as DTC No. P0300 f*2 f
(05−490)
P0304
Cylinder 4 Misfire Detected S Same as DTC No. P0300 f*2 f
(05−490)
P0305
Cylinder 5 Misfire Detected S Same as DTC No. P0300 f*2 f
(05−490)
P0306
Cylinder 6 Misfire Detected S Same as DTC No. P0300 f*2 f
(05−490)
S Knock sensor 1
P0325 Knock Sensor 1 Circuit (Bank 1
S Knock sensor 1 (loose) f f
(05−506) or Single Sensor)
S ECM
S Short in knock sensor 1 circuit
P0327 Knock Sensor 1 Circuit Low
S Knock sensor 1 f f
(05−506) Input (Bank 1 or Single Sensor)
S ECM
S Open in knock sensor 1 circuit
P0328 Knock Sensor 1 Circuit High
S Knock sensor 1 f f
(05−506) Input (Bank 1 or Single Sensor)
S ECM
S Knock sensor 2
P0330
Knock Sensor 2 Circuit (Bank 2) S Knock sensor 2 (loose) f f
(05−506)
S ECM
S Short in knock sensor 2 circuit
P0332 Knock Sensor 2 Circuit Low
S Knock sensor 2 f f
(05−506) Input (Bank 2)
S ECM
S Open in knock sensor 2 circuit
P0333 Knock Sensor 2 Circuit High
S Knock sensor 2 f f
(05−506) Input (Bank 2)
S ECM
S Open or short in crankshaft position sensor circuit
P0335 Crankshaft Position Sensor ”A” S Crankshaft position sensor
f f
(05−513) Circuit S Crankshaft timing pulley
S ECM

2004 HIGHLANDER REPAIR MANUAL (RM1086U)

05−396
DIAGNOSTICS − SFI SYSTEM (3MZ−FE)

DTC No.
Detection Item Trouble Area MIL*1 Memory
(See Page)
P0339 Crankshaft Position Sensor ”A”
S Same as DTC No. P0335 ¾ f
(05−513) Circuit Intermittent
S Open or short in VVT sensor circuit
S VVT sensor
P0340 Camshaft Position Sensor ”A”
S Camshaft timing pulley f f
(05−517) Circuit (Bank 1 or Single Sensor)
S Timing belt has jumped a tooth
S ECM
Camshaft Position Sensor ”A”
P0341
Circuit Range/Performance S Same as DTC No. P0340 f f
(05−517)
(Bank 1 or Single Sensor)
P0345 Camshaft Position Sensor ”A”
S Same as DTC No. P0340 f f
(05−517) Circuit (Bank 2)
Camshaft Position Sensor ”A”
P0346
Circuit Range/Performance S Same as DTC No. P0340 f f
(05−517)
(Bank 2)
S Ignition system
S Open or short in IGF1 or IGT1 circuit from ignition coil with
P0351*4 Ignition Coil ”A” Primary/Sec-
igniter to ECM (ignition coil circuit 1) f f
(05−521) ondary Circuit
S Ignition coil with igniter (ignition coil 1)
S ECM
S Ignition system
S Open or short in IGF1 or IGT2 circuit from ignition coil with
P0352*4 Ignition Coil ”B” Primary/Sec-
igniter to ECM (ignition coil circuit 2) f f
(05−521) ondary Circuit
S Ignition coil with igniter (ignition coil 2)
S ECM
S Ignition system
S Open or short in IGF1 or IGT3 circuit from ignition coil with
P0353*4 Ignition Coil ”C” Primary/Sec-
igniter to ECM (ignition coil circuit 3) f f
(05−521) ondary Circuit
S Ignition coil with igniter (ignition coil 3)
S ECM
S Ignition system
S Open or short in IGF1 or IGT4 circuit from ignition coil with
P0354*4 Ignition Coil ”D” Primary/Sec-
igniter to ECM (ignition coil circuit 4) f f
(05−521) ondary Circuit
S Ignition coil with igniter (ignition coil 4)
S ECM
S Ignition system
S Open or short in IGF1 or IGT5 circuit from ignition coil with
P0355*4 Ignition Coil ”E” Primary/Sec-
igniter to ECM (ignition coil circuit 5) f f
(05−521) ondary Circuit
S Ignition coil with igniter (ignition coil 5)
S ECM
S Ignition system
S Open or short in IGF1 or IGT6 circuit from ignition coil with
P0356*4 Ignition Coil ”F” Primary/Sec-
igniter to ECM (ignition coil circuit 6) f f
(05−521) ondary Circuit
S Ignition coil with igniter (ignition coil 6)
S ECM
S Gas leakage in exhaust system
P0420 Catalyst System Efficiency Be- S A/F sensor (bank 1 sensor 1)
f f
(05−531) low Threshold (Bank 1) S Heated oxygen sensor (bank 1 sensor 2)
S Three−way catalytic converter (inside exhaust manifold)
S Gas leakage in exhaust system
P0430 Catalyst System Efficiency Be- S A/F sensor (bank 2 sensor 1)
f f
(05−531) low Threshold (Bank 2) S Heated oxygen sensor (bank 2 sensor 2)
S Three−way catalytic converter (inside exhaust manifold)

2004 HIGHLANDER REPAIR MANUAL (RM1086U)

 05−397
DIAGNOSTICS − SFI SYSTEM (3MZ−FE)

DTC No.
Detection Item Trouble Area MIL*1 Memory
(See Page)
S Vacuum hose has cracks, holes, or is blocked, damaged or
disconnected
S Fuel tank cap incorrectly installed
S Fuel tank cap has cracks, or is damaged
S Open or short in vapor pressure sensor circuit
S Vapor pressure sensor
Evaporative Emission Control
P0441 S Open or short in VSV circuit for EVAP
System f f
(05−537) S EVAP VSV
Incorrect Purge Flow
S Open or short in VSV circuit for CCV
S CCV
S Fuel tank has cracks, holes, or is damaged
S Charcoal canister has cracks, holes, or is damaged
S Fuel tank over fill check valve has cracks, or is damaged
S ECM
Evaporative Emission Control
P0442
System Leak detected (small S Same as DTC No. P0441 f f
(05−537)
leak)
P0446 Evaporative Emission Control
S Same as DTC No. P0441 f f
(05−537) System Vent Control Circuit
Evaporative Emission Control S Open or short in vapor pressure sensor circuit
P0451
System Pressure Sensor/Switch S Vapor pressure sensor f f
(05−567)
Range/Performance S ECM
Evaporative Emission Control S Open in vapor pressure sensor circuit
P0452
System Pressure Sensor/Switch S Vapor pressure sensor f f
(05−567)
Low Input S ECM
Evaporative Emission Control S Short in vapor pressure sensor circuit
P0453
System Pressure Sensor/Switch S Vapor pressure sensor f f
(05−567)
High Input S ECM
Evaporative Emission Control
P0455
System Leak Detected (gross S Same as DTC No. P0441 f f
(05−537)
leak)
Evaporative Emission Control
P0456
System Leak Detected (very S Same as DTC No. P0441 f f
(05−537)
small leak)
S Open or short in VSS circuit
S VSS sensor
P0500
Vehicle Speed Sensor ”A” S Combination meter f f
(05−572)
S ECM
S Skid control ECU
P0503 Vehicle Speed Sensor ”A” Inter-
S Same as DTC No. P0500 ¾ f
(05−572) mittent/Erratic/High
S Short in stop lamp switch signal circuit
P0504
Brake Switch ”A”/”B” Correlation S Stop lamp switch ¾ f
(05−575)
S ECM
S Electric throttle control system
P0505
Idle Air Control System S Air induction system f f
(05−581)
S PCV hose connection
P0560 S Open in back−up power source circuit
System Voltage f f
(05−584) S ECM
P0604 Internal Control Module Random
S ECM f f
(05−587) Access Memory (RAM) Error
P0606
ECM/PCM Processor S ECM f f
(05−587)
P0607
Control Module Performance S ECM f f
(05−587)

2004 HIGHLANDER REPAIR MANUAL (RM1086U)

05−398
DIAGNOSTICS − SFI SYSTEM (3MZ−FE)

DTC No.
Detection Item Trouble Area MIL*1 Memory
(See Page)
S Short in PNP switch circuit
P0617 S PNP switch
Starter Relay Circuit High f f
(05−589) S Ignition switch
S ECM
P0657 Actuator Supply Voltage Circuit /
S ECM f f
(05−587) Open
S Short in PNP switch circuit
P0705 Transmission Range Sensor Cir-
S PNP switch f f
(05−990) cuit Malfunction (PRNDL Input)
S ECM
P0710 Transmission Fluid Temperature
S Electronic controlled automatic transmission (ECT) f f
(05−996) Sensor ”A” Circuit
P0711 Transmission Fluid Temperature
S Electronic controlled automatic transmission (ECT) f f
(05−1000) Sensor ”A” Performance
P0712 Transmission Fluid Temperature
S Electronic controlled automatic transmission (ECT) f f
(05−996) Sensor ”A” Circuit Low Input
P0713 Transmission Fluid Temperature
S Electronic controlled automatic transmission (ECT) f f
(05−996) Sensor ”A” Circuit High Input
P0717 Input/Turbine Speed Sensor ”A”
S Electronic controlled automatic transmission (ECT) f f
(05−1003) Circuit No Signal
P0724
Brake Switch ”B” Circuit High S Electronic controlled automatic transmission (ECT) f f
(05−1006)
Torque Converter Clutch Sole-
P0741
noid Performance (Shift Solenoid S Electronic controlled automatic transmission (ECT) f f
(05−1010)
Valve DSL)
Pressure Control Solenoid ”A”
P0746
Performance (Shift Solenoid S Electronic controlled automatic transmission (ECT) f f
(05−1015)
Valve SL1)
Pressure Control Solenoid ”A”
P0748
Electrical (Shift Solenoid Valve S Electronic controlled automatic transmission (ECT) f f
(05−1019)
SL1)
P0766 Shift Solenoid ”D” Performance
S Electronic controlled automatic transmission (ECT) f f
(05−1022) (Shift Solenoid Valve S4)
P0771 Shift Solenoid ”E” Performance
S Electronic controlled automatic transmission (ECT) f f
(05−1027) (Shift Solenoid Valve SR)
Pressure Control Solenoid ”B”
P0776
Performance (Shift Solenoid S Electronic controlled automatic transmission (ECT) f f
(05−1032)
Valve SL2)
Pressure Control Solenoid ”B”
P0778
Electrical (Shift Solenoid Valve S Electronic controlled automatic transmission (ECT) f f
(05−1037)
SL2)
P0793 Intermediate Shaft Speed Sen-
S Electronic controlled automatic transmission (ECT) f f
(05−1040) sor ”A” Circuit No Signal
Pressure Control Solenoid ”C”
P0796
Performance (Shift Solenoid S Electronic controlled automatic transmission (ECT) f f
(05−1044)
Valve SL3)
Pressure Control Solenoid ”C”
P0798
Electrical (Shift Solenoid Valve S Electronic controlled automatic transmission (ECT) f f
(05−1049)
SL3)
P0982
Shift Solenoid ”D” Control Low S Electronic controlled automatic transmission (ECT) f f
(05−1052)
P0983
Shift Solenoid ”D” Control High S Electronic controlled automatic transmission (ECT) f f
(05−1052)
Pressure Control Solenoid ”E”
P0985
Performance (Shift Solenoid S Electronic controlled automatic transmission (ECT) f f
(05−1055)
Valve SR)

2004 HIGHLANDER REPAIR MANUAL (RM1086U)

 05−399
DIAGNOSTICS − SFI SYSTEM (3MZ−FE)

DTC No.
Detection Item Trouble Area MIL*1 Memory
(See Page)
Pressure Control Solenoid ”E”
P0986
Electrical (Shift Solenoid Valve S Electronic controlled automatic transmission (ECT) f f
(05−1055)
SR)
S Open in throttle control motor circuit
P2102 Throttle Actuator Control Motor
S Throttle control motor f f
(05−596) Circuit Low
S ECM
S Short in throttle control motor circuit
S Throttle control motor
P2103 Throttle Actuator Control Motor
S Throttle body f f
(05−596) Circuit High
S Throttle valve
S ECM
S Throttle control motor circuit
P2111 Throttle Actuator Control System S Throttle control motor
f f
(05−600) − Stuck Open S Throttle body
S Throttle valve
P2112 Throttle Actuator Control System
S Same as DTC No. P2111 f f
(05−600) − Stuck Closed
P2118 Throttle Actuator Control Motor S Open in ETCS power source circuit
f f
(05−603) Current Range/Performance S ECM
P2119 Throttle Actuator Control Throttle S ETCS
f f
(05−608) Body Range/Performance S ECM
P2120 Throttle/Pedal Position Sensor/ S Accelerator pedal position sensor
f f
(05−610) Switch ”D” Circuit S ECM
Throttle/Pedal Position Sensor/ S Accelerator pedal position sensor circuit
P2121
Switch ”D” Circuit Range/Perfor- S Accelerator pedal position sensor f f
(05−618)
mance S ECM
S Accelerator pedal position sensor
P2122 Throttle/Pedal Position Sensor/ S VCP1 circuit open
f f
(05−610) Switch ”D” Circuit Low Input S VPA1 circuit open or ground short
S ECM
S Accelerator pedal position sensor
P2123 Throttle/Pedal Position Sensor/
S EPA circuit open f f
(05−610) Switch ”D” Circuit High Input
S ECM
P2125 Throttle/Pedal Position Sensor/
S Same as DTC No. P2120 f f
(05−610) Switch ”E” Circuit
S Accelerator pedal position sensor
P2127 Throttle/Pedal Position Sensor/ S VCP2 circuit open
f f
(05−610) Switch ”E” Circuit Low Input S VPA2 circuit open or ground short
S ECM
S Accelerator pedal position sensor
P2128 Throttle/Pedal Position Sensor/
S EPA2 circuit open f f
(05−610) Switch ”E” Circuit High Input
S ECM
Throttle Pedal Position Sensor/ S VTA1 and VTA2 circuit are short circuited
P2135
Switch ”A”/”B” Voltage Correla- S Throttle position sensor (built in throttle body) f f
05−449
tion S ECM
Throttle Pedal Position Sensor/ S VPA1 and VPA2 circuit are short circuited
P2138
Switch ”D”/”E” Voltage Correla- S Accelerator pedal position sensor f f
(05−610)
tion S ECM

2004 HIGHLANDER REPAIR MANUAL (RM1086U)

05−400
DIAGNOSTICS − SFI SYSTEM (3MZ−FE)

DTC No.
Detection Item Trouble Area MIL*1 Memory
(See Page)
S Open or short in A/F sensor (bank 1 sensor 1) circuit
S A/F sensor (bank 1 sensor 1)
S A/F sensor (bank 1 sensor 1) heater
S A/F relay
P2195*3 Oxygen (A/F) Sensor Signal S A/F sensor heater and relay circuit
f f
(05−622) Stuck Lean (Bank 1 Sensor 1) S Air induction system
S Fuel pressure
S Injector
S PCV hose connection
S ECM
P2196*3 Oxygen (A/F) Sensor Signal
S Same as DTC No. P2195 f f
(05−622) Stuck Rich (Bank 1 Sensor 1)
S Open or short in A/F sensor (bank 2 sensor 1) circuit
S A/F sensor (bank 2 sensor 1)
S A/F sensor (bank 2 sensor 1) heater
S A/F relay
P2197*3 Oxygen (A/F) Sensor Signal S A/F sensor heater and relay circuit
f f
(05−622) Stuck Lean (Bank 2 Sensor 1) S Air induction system
S Fuel pressure
S Injector
S PCV hose connection
S ECM
P2198*3 Oxygen (A/F) Sensor Signal
S Same as DTC No. P2197 f f
(05−622) Stuck Rich (Bank 2 Sensor 1)
S Open or short in A/F sensor (bank 1 sensor 1) circuit
S A/F sensor (bank 1 sensor 1)
Oxygen Sensor Pumping Cur-
P2238*3 S A/F sensor (bank 1 sensor 1) heater
rent Circuit Low (for A/F sensor) f f
(05−635) S A/F relay
(Bank 1 Sensor 1)
S A/F sensor heater and relay circuit
S ECM
Oxygen Sensor Pumping Cur-
P2239*3
rent Circuit High (for A/F sensor) S Same as DTC No. P2238 f f
(05−635)
(Bank 1 Sensor 1)
S Open or short in A/F sensor (bank 2 sensor 1) circuit
S A/F sensor (bank 2 sensor 1)
Oxygen Sensor Pumping Cur-
P2241*3 S A/F sensor (bank 2 sensor 1) heater
rent Circuit Low (for A/F sensor) f f
(05−635) S A/F relay
(Bank 2 Sensor 1)
S A/F sensor heater and relay circuit
S ECM
Oxygen Sensor Pumping Cur-
P2242*3
rent Circuit High (for A/F sensor) S Same as DTC No. P2241 f f
(05−635)
(Bank 2 Sensor 1)
Oxygen Sensor Reference
P2252*3
Ground Circuit Low (for A/F sen- S Same as DTC No. P2238 f f
(05−635)
sor) (Bank 1 Sensor 1)
Oxygen Sensor Reference
P2253*3
Ground Circuit High (for A/F sen- S Same as DTC No. P2238 f f
(05−635)
sor) (Bank 1 Sensor 1)
Oxygen Sensor Reference
P2255*3
Ground Circuit Low (for A/F sen- S Same as DTC No. P2241 f f
(05−635)
sor) (Bank 2 Sensor 1)
Oxygen Sensor Reference
P2256*3
Ground Circuit High (for A/F sen- S Same as DTC No. P2241 f f
(05−635)
sor) (Bank 2 Sensor 1)
P2716 Pressure Control Solenoid ”D”
S Electronic controlled automatic transmission (ECT) f f
(05−1058) Electrical
P2769
DSL Solenoid Circuit Low S Electronic controlled automatic transmission (ECT) f f
(05−1061)

2004 HIGHLANDER REPAIR MANUAL (RM1086U)

 05−401
DIAGNOSTICS − SFI SYSTEM (3MZ−FE)

DTC No.
Detection Item Trouble Area MIL*1 Memory
(See Page)
P2770
DSL Solenoid Circuit High S Electronic controlled automatic transmission (ECT) f f
(05−1061)
S Open or short in A/F sensor (bank 1 sensor 1) circuit
S A/F sensor (bank 1 sensor 1)
S A/F sensor heater
S A/F relay
P2A00 A/F Sensor Circuit Slow Re- S A/F sensor heater and relay circuit
f f
(05−642) sponse (Bank 1 Sensor 1) S Air induction system
S Fuel pressure
S Injector
S PCV hose connection
S ECM
S Open or short in A/F sensor (bank 2 sensor 1) circuit
S A/F sensor (bank 2 sensor 1)
S A/F sensor heater
S A/F relay
P2A03 A/F Sensor Circuit Slow Re- S A/F sensor heater and relay circuit
f f
(05−642) sponse (Bank 2 Sensor 1) S Air induction system
S Fuel pressure
S Injector
S PCV hose connection
S ECM

HINT:
*1: MIL is illuminated.
*2: MIL is illuminated or flashes continuously.
*3: Although the title (DTC description) says ”oxygen sensor”, this DTC is related to the ”A/F sensor”.
*4: This DTC indicates a malfunction related to primary circuit.

2004 HIGHLANDER REPAIR MANUAL (RM1086U)