0% found this document useful (0 votes)
1K views6 pages

ECU - Engine Control Unit Diagnostic Trouble Codes - 6135 JD Control Unit Level 15

The document lists diagnostic trouble codes (DTCs) detected by the engine control unit (ECU) of a John Deere 6135 control unit. It describes 26 DTCs related to issues such as high/low fuel pressure and temperature, high coolant temperature, low oil pressure, and other engine operating parameters being out of range. Each DTC is identified by a specific code number, and indicates the priority level and potential effects, such as derated engine performance or an immediate engine stop.

Uploaded by

Benjamin House
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as DOCX, PDF, TXT or read online on Scribd
0% found this document useful (0 votes)
1K views6 pages

ECU - Engine Control Unit Diagnostic Trouble Codes - 6135 JD Control Unit Level 15

The document lists diagnostic trouble codes (DTCs) detected by the engine control unit (ECU) of a John Deere 6135 control unit. It describes 26 DTCs related to issues such as high/low fuel pressure and temperature, high coolant temperature, low oil pressure, and other engine operating parameters being out of range. Each DTC is identified by a specific code number, and indicates the priority level and potential effects, such as derated engine performance or an immediate engine stop.

Uploaded by

Benjamin House
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as DOCX, PDF, TXT or read online on Scribd
You are on page 1/ 6

ECU - Engine Control Unit

Diagnostic Trouble Codes (6135 JD


Control Unit, Level 15)
ECU - Engine Control Unit Diagnostic Trouble Codes (6135 JD Control Unit, Level
15)
Control Indicator
SPN FMI Priority Description Effect
Unit Light
ECU 94 03 2 Fuel Pressure Input Fuel pressure is not
Warning
Voltage High monitored.
ECU 94 04 2 Fuel Pressure Input Fuel pressure is not
Warning
Voltage Low monitored.
ECU 94 17 2 Fuel Pressure Low - Low pressure in fuel
Least Severe Level pump circuit.
Restriction in the low-
Warning
pressure system due to
a plugged screen or
pump failure.
ECU 97 03 2 Water In Fuel Signal Presence of water in
Warning
Voltage High fuel is not monitored.
Water In Fuel Signal Presence of water in
ECU 97 04 2 Warning
Voltage Low fuel is not monitored.
Water has collected in
ECU 97 16 1 Stop Water in Fuel Detected
the separator bowl.
Loss of engine oil
Engine Oil Pressure pressure. Oil pressure
ECU 100 01 1 Stop Extremely Low - Most switch shorted to low
Severe Level voltage source. Oil
pressure switch failure.
Engine Oil Pressure Engine oil pressure is
ECU 100 03 2 Warning
Input Voltage High not monitored.
Engine Oil Pressure Engine oil pressure is
ECU 100 04 2 Warning
Input Voltage Low not monitored.
Engine Oil Pressure
Loss of engine oil
ECU 100 18 2 Warning Low - Moderately
pressure.
Severe Level
Oil pressure detected at
Engine Oil Pressure
zero engine speed due
ECU 100 31 2 Warning Detected at Zero
to open ground in the
Engine Speed
sensor circuit.
Boost Pressure Input Boost pressure is not
ECU 102 03 2 Warning
Voltage High monitored.
Boost Pressure Input Boost pressure is not
ECU 102 04 2 Warning
Voltage Low monitored.
Turbocharger Speed
ECU 103 00 2 Warning High - Most Severe Erratic VGT operation.
Level
Manifold Air Cooling system
ECU 105 00 1 Stop Temperature Too High performance has
- Most Severe Level degraded or failed.
Manifold Air Manifold air
ECU 105 03 2 Warning Temperature Input temperature is not
Voltage High monitored.
Manifold Air Manifold air
ECU 105 04 2 Warning Temperature Input temperature is not
Voltage Low monitored.
Manifold Air
Cooling system
Temperature
ECU 105 15 2 Warning performance has
Moderately High -
degraded or failed.
Least Severe Level
Manifold Air
Temperature Cooling system
ECU 105 16 2 Warning Moderately High - performance has
Moderately Severe degraded or failed.
Level

ZX09263,0002ACA -19-22JUL08-1/3

ECU - Engine Control Unit Diagnostic Trouble Codes (6135 JD Control Unit, Level
15)
Control Indicator
SPN FMI Priority Description Effect
Unit Light
Engine Coolant Cooling system
ECU 110 00 1 Stop Temperature Too High performance has
- Most Severe Level degraded or failed.
Engine Coolant Engine coolant
ECU 110 03 2 Warning Temperature Input temperature is not
Voltage High monitored.
Engine Coolant Engine coolant
ECU 110 04 2 Warning Temperature Input temperature is not
Voltage Low monitored.
Engine Coolant Cooling system
ECU 110 15 2 Warning Temperature High - performance has
Least Severe Level degraded or failed.
ECU 110 16 2 Warning Engine Coolant Cooling system
Temperature High -
performance has
Moderately Severe
degraded or failed.
Level
Engine temperature has
not risen into the
Engine Coolant normal operating range
ECU 110 17 2 Warning Temperature Low - under operating
Least Severe Level conditions. Likely due
to stuck open
thermostat.
The engine control unit
Engine Coolant Level
ECU 111 01 1 Stop senses a low engine
Low
coolant level.
Fuel pressure is below
Fuel Pressure Too lower limit due to a
ECU 157 01 1 Stop Low - Most Severe plugged fuel filter or
Level loss of prime in the fuel
system.
Fuel Pressure Sensor Fuel pressure is not
ECU 157 03 2 Warning
Input Voltage High monitored.
Fuel Pressure Sensor Fuel pressure is not
ECU 157 04 1 Stop
Input Voltage Low monitored.
Faulty pressure
Fuel Pressure High -
regulating valve or
ECU 157 16 2 Warning Moderately Severe
sensor. Plugged internal
Level
housing screen.
Fuel pressure is below
Fuel Pressure Too lower limit due to a
ECU 157 18 2 Warning Low - Moderately plugged fuel filter or
Severe Level loss of prime in the fuel
system.
Fuel Temperature Too Cooling system
ECU 174 00 1 Stop High - Most Severe performance has
Level degraded or failed.
Fuel Temperature Fuel temperature is not
ECU 174 03 2 Warning
Input Voltage High monitored.
Fuel Temperature Fuel temperature is not
ECU 174 04 2 Warning
Input Voltage Low monitored.
Fuel Temperature Cooling system
ECU 174 16 2 Warning High - Moderately performance has
Severe Level degraded or failed.
ECU 189 00 1 Stop Rated Engine Speed A condition exists
which is causing the
engine to derate.
EGR Temperature Too
High loads with poor
ECU 412 00 1 Stop High - Most Severe
EGR cooling.
Level
EGR Temperature EGR temperature is not
ECU 412 03 2 Warning
Input Voltage High monitored.
EGR Temperature EGR temperature is not
ECU 412 04 2 Warning
Input Voltage Low monitored.

ZX09263,0002ACA -19-22JUL08-2/3

ECU - Engine Control Unit Diagnostic Trouble Codes (6135 JD Control Unit, Level
15)
Control Indicator
SPN FMI Priority Description Effect
Unit Light
EGR Temperature Too
High loads with poor
ECU 412 15 2 Warning High - Least Severe
EGR cooling.
Level
EGR Temperature Too
High loads with poor
ECU 412 16 1 Stop High - Moderately
EGR cooling.
Severe Level
Electronic Injector A short to battery has
ECU 611 03 1 Stop Wiring Shorted To occurred in the injector
Power Source wiring.
Electronic Injector A short to ground has
ECU 611 04 1 Stop Wiring Shorted To occurred in the injector
Ground wiring.
Problem With Supply The battery supply to the
ECU 627 01 2 Warning Voltage to Electronic
ECU is unusually low.
Injection Nozzle The ECU has failed.
The ECU has failed.
Engine Control Unit
ECU 629 13 1 Stop Reprogram / replace
Error
ECU.
VGT Temperature Too VGT temperature too
ECU 641 16 2 Warning High - Moderately high due to restricted air
Severe Level flow or excessive EGR.
ECU Temperature Too
Inadequate cooling of
ECU 1136 00 1 Stop High - Most Severe
the area around ECU.
Level
ECU 1136 16 2 Warning ECU Temperature Too Inadequate cooling of
High - Moderately the area around ECU.
Severe Level
Compressor inlet
Compressor Inlet Sensor
ECU 1172 03 2 Warning temperature is not
Input Voltage High
monitored.
Compressor inlet
Compressor Inlet Sensor
ECU 1172 04 2 Warning temperature is not
Input Voltage Low
monitored.
Turbine Inlet
Fuel-to-air ratio too
ECU 1180 00 1 Stop Temperature High -
high.
Most Severe Level
Turbine Inlet
Temperature High - Fuel-to-air ratio too
ECU 1180 16 2 Warning
Moderately Severe high.
Level
One of the derate
ECU 1569 31 2 Warning Fuel Derate conditions exists on the
engine.
Charge Air Cooler Charge air cooler or
ECU 2630 00 1 Stop Temperature Too High - radiator needs to be
Most Severe Level cleaned.
Charge Air Cooler Charge air cooler
ECU 2630 03 2 Warning Sensor Input Voltage temperature is not
High monitored.
Charge Air Cooler Charge air cooler
ECU 2630 04 2 Warning Sensor Input Voltage temperature is not
Low monitored.
Charge Air Cooler Charge air cooler or
ECU 2630 15 2 Warning Temperature Too High - radiator needs to be
Least Severe Level cleaned.
Charge Air Cooler
Charge air cooler or
Temperature Too High -
ECU 2630 16 2 Warning radiator needs to be
Moderately Severe
cleaned.
Level
High compressor outlet
Compressor Outlet
temperature due to high
Temperature Too High -
ECU 2790 16 2 Warning ambient temperature or
Moderately Severe
charge air cooler
Level
restriction.

NOTE: If diagnostic trouble codes appear, which are not listed here, contact your John
Deere dealer.

You might also like