Page No..........

Dr. D. Y. Patil Polytechnic Roll No. . .

Empeaimend No. 3.

Title
Paepare the detail specification foa qiven
item uSigDSR

fathuwoak in ezcawation in foundation=

fmcavation faundation trehdhes shcall be
dug ou to the entaact wih af foundadion conc2ek
the Siles shal be vemticcu f the sail is
hot gaod k daes not pemit veatical sides he
Sid es should be _shoped bachor prote.cted
shalnot
uih timbea S hozim fmcavaled ean th
be placed with i Iml3) of he edge of tzenches

finish of trench-
be
The bottam of foundoadion tzerhes shall
p2efectly lewelled hoth longiludinall q k
tzahsvens
the sides of tzench shall bedaessed pezfectH
Ventical fz0n_ bottam up to LensB thickness
of
widthas|
losse coançiete may belaid to heia ezact
per desigh the bed af trench shall be liahBly
ate & uwell Tammed.
 20 Page No...9

Dr. D. Y. Patil Polytechnic Roll No. .

finds-
Valuable o7 madeaials found
Uhy47easuze
be paopeaty of
duaig en.cka ion , shall
g0ueamend

watea infoundation-
wader it any accUmalades in the taehch
Should he bealled o7 pumped Qd with 0ut cny
etra payameni neceSSry paecautiah
shall be1ukeh to pzeyenl Sugiace watem
toenteg into taench

Tzench ilina-
APte cantQde has been laid masonzs_ has
been constuded the e ma'nina po2iioh of
the renches shalL be filled up wih ean th ip
layen af 1S.cm6")
medslgnent-
he mesuaemeni ofexcHuation should
betuken in Cu:m (Cu.f)_as fo2
e
tectonaulag taench bottom uid th af conczete
2|lime cancaele infoundajion-
Haleatha
Materials
A mal erials
shall be as pe stuhdcuod
epacticoadian caargse aggaegade
hand ell buaht aa ave7 shalbe 0E
bumnt baick hala-
 21
Dr. D. Y. Patil Polytechnic Page No..2.
Roll No. .

of 40mm dtage i91

shall be deepcheay red
0T Copper calau shol) be cleoh, {ree fzom
dusdint othea foreiyh_matteS
Balas which appeos t
signs Of saltpene shall bnot poaOuS an shows
Brick ballas shal pass be.usedL
of s2-6mm th7ough Squase mesh
not moae than 20 peg cent
passhaouah amesh of 25mm. shall
Fine ma20ate shall be of
Ox nden as peafiedb clean suakhi o7 sand
dust diTt b_ foxeian mattems faee fzom
m cd e Of welL humnt 5um khi shall be
bzichs 07 batk bats
shall pass thaaugh a sieve of -b
pe sq-cm Suakbi is pmefencable meshes
foz bett e
C.oncre te

Paa pontion-
The conc2ete shcul consis} aflcu
m of_
brick ballast,o.32 cu m ofsua.khi
olo cu m of white lime in lsand az indez
papoztian
miainaa-
mizinashall be done gn clean watez tiat
masonTy plad Foam of isofficient size.
laying cempaclient-size compaciim9
Aed af foundat" tzench shal liahtly
spzinkled with watey befone concrete islaid
concneBe shall_laid slouly &gently in laye at
 22 Page No.....
Dr. D. Y. Patil Roll No.
Polytechnic
nat_moz ta maze hah 20cm

Cuaing-a
curina cftee comple tion shalLbe ept uet
fo peaiad of at lest 7days
3 lime conczeBe in 2oof te 20cing
Mate2iculs-
Almatezla shall be af stand azd speaica~iOn|
Caaaseagg?e qate shall be of well buani oz
avea bugnt brick ballas| of 25mmgauge
lt
Shal be cleah, faee fzom dust dizt So
otheaz
foreqn madtea it shall be hamaqeniaus in
Fetume k2Ouahly cubic in shope Balck
Ball ast in teztuae 2ouahly Cubical
in
shape. Baick Ballast shoudd he such as
t o paSS hzouah asquane mesh of 375 cm
no9 mgae thab 20 shall pass ha ouqh
a mesh ef 20Lm Ahy aejected matezia)
Shall be zemaved faom s1teuithin 24 Has
Pine aagzegade shall be oE Suakhi clean
free fzom dust ,dit faze gih mattee
sakh
shall be made fzomwell: huaht baick lshall
passhraoug h_asczeeh af 25 eshes pe 2
Sqlcm (144_meshes pe sq/ch)
Paapo2 tion -
Cancaete shal_consist aElcu: hzick
ballast
 Page N o . . A . . . . .

Roll No. * * ' '

Dr. D. Y. Patil Polytechnic

0:19Cum_white lime
O.36 cu.m of Sun khË_&
LPaapoation lo0 :36: 18by yolume

Mining
shall he similaz to lime concgeBe ih_
miina
foun dation
layina consolidath-
wth
Suaface shall be liahtly Spainkeled
wate & then_Loncaeleshall be
laid selstouly
gentelyhot thaown)_in layeg sous
to hdle
thickness after
The7equized slopespecified lightly
campacdion he conczete shall be
L
rCt ammed uith 6kaL2hs) 2a mnezs
dunina-p2eliminany cammig the suztace Shall
taowe
be peafectly levelled by_meansOf
staasaht edqe t Sp7it_evel theConczeke
COnsalidaked by two 20ws of laboures sitim|
close beatigconcaete with ood.en
thapis& movin Fo2 wandkbackwcad coveaig
the agea he whole suaface.

Cuing
he concaete_4 hall be kepB wet foza
foatnight he uuettihg should bedone hy
cavestng 60nd &wateala faequently by-
cter
 Page No.:...
Dr. D. Y. Patil
Polytechnic Roll No. .

4 cement canczele 1:2: 4=

mat eaia-
Aggaegcade shallbe Of inuea tmakea la
Shakdbe Clea dense haa d.saund duraDi
hoh -abs.en beut capable to makeaood hoha
with moata
CAr se aggaeqcde_Shall be sf hcud baoke2
Stone Af gaanite: fzee fzOm dusLdiziAOthe
Pazeg ih matess he sta ba ballast
sh0ua
be of 20mm ( a4") size kdown & allshouk
be reBainedin 5mm Squaae meshl ae
oad e should not be ezcecd 42percent.
fine agazeg.cte shall be coamse lconsisti
of haad shd?p & angulaz qacu'ns shall pass
thaough Scaeen af 5mm l3/6") Square
mesh.
Cemend shall be fzesh pozt leund cement Of
standoad IsI Speci fication.
aciez shoudd be cleah & faee from
allkoline

Paapoation -
The paapoztion of_concaele Shall be :2:4
ascement: scund: stoMeiballasi by val ules
othea wlse specified minim1un_compaessive
stzength OF concete is :2-:4pmapoz tiah
shal! he 4o ka pen sq Cman 7days
 2 Page No..25

Dr. D. Y. Patil Polytechnic Roll No.... *'***

Stone daaeaate should sand shouuld be

mesuze by volume uwith boues ohe bag9
Otcement Is consid en_as u30 Cu-ml2Cuft|
Size af meo3ua ed ho2_is 30cm A30Cm 135cm
0735c m3hem X29cm

Hond mixina--
mizina done /n_ masonaru_platkoam azizoh
tzCLy fo2 Conczete of 1:2:4 pmapoztion.fizst
tuo bo2es of Sand a.he_bca of cene Shall
be miaed da thaoughly then thisday miz
of cemend sand shallbe placedouea staach
o f 4ho2eS A£ stone_ca4zegde

machihe mining-
Stone ballast sand cem end shal be put
into the cemed conczee miMe to haure the
C equned paapoatiun he machihe is
ne voveld to min _matealauday & heh natez
shall be done added gzadually to the 2equize
quantity of 25 t0 10 lites

Slump zZ
Ked Regulan slump test shauld be cam2ied
Owt tocohtnal he addifiOn of water to0
mouintan gequied cohsistercy
 Page No...2.6.

Roll No...

Dr. D. Y. Patil Polytechnic

HaamiwouK-- shall he
tozmuwo2 k Centeaing & suttea ing specificu"
penstcundaad
p2oYlde d a s eqwred
as
conczete to confine to kee p_
befoae loving ea_suaface shawd
Cancaeein pasiti
on_the inh
_concaeBestic kia to it
paeveni
be ailed to

lain eas
concaete shall be laid-qenly
_in lay
e.ceeding Scml6") g compacted by
hot woodeh
uith
pinning mithods Xlampin
tcumpeaS 0a mechanlca
1hzato7S

Cui
AHeabout two hous wheh corcete has
beacnto haaden. iB shal)-be kepi
damp bs-
covering i t h nei gunny bags

5 Reinfoacement conczete Rcc)-

Steel-
Stee 2einfozcina baa shall be _of mild
steel oz defozmed seel oFstundand specificadiah
shall be faee faom_coTision loss e 2us
Scaes oila2ease, painte tc h e steel
baa
shoul be zound & capable of hejng_ben+
doubled ove) u»ith0d taactuaeBaas
shall be tooked _DEni_Clccunade 2 placed
i Osilion_aG peadesignd2a wina & bouhd
 1 Page No..21....

Dr. D. Y. Patil Polytechnic Roll No. * * * ' * *

Togethea tiqhd uwith 20 S w& anneleod Stee)

wine ad heia pnind of intenset 10n

Cendegina shulleaina
Cenieaina shudlening shall be made
with
tlnben- 00 stee plate clase tlahi t
pTevehi leakage 0z m02atun,wihpecesSaTy
PTOnsb2acina wedges sufficiently Gizohg
stahle shouud not uield pn layina cohcaete
i n such a wcy Hhad they cauh be slarkehed &
gembved aaadually ithoui distaehlhg conc7ete_
No plas feziha should be made an concaeio
Sugtace_

Prapon tim of cemeni_comaele-

cement concehe Shall be :2.:4 prapotian
hyvalume foa5lab beam,k elintel a:3
papoation foa coluwmn_

motezial fom concaehe-

cement, sand &coaase agazeqate shalLhe
Same as fag cement coneatte in iem the stohe
aggaegate shall_be 20mn tocmm 3/4" to l/4")_
qlye Specified.

ming=
Some as foz cemeut Canczete.
 28 Page No..4...

Roll No.. ***.

Dr. D. Y. Patil Polytechnic

louing _the
teaing
shutte

Befoae laying. the conca sHkdizt Hhe contaete

sha be_clean fzee fzom du Ihcuse
shall be depasited in its inal_posiflon
to pla.ce
ofcalaumns wallit isdesiu
caze shauld be taken
Concaete in full heiqhd
uhile mizin &_placa of concgete- hy_meuhanica
Lonekeshould b comparted
Vitbaatiena machine uhtil dens
e cancnefe
Continue daa.
ISahtaihed Thevibation shall
the entize peniod afplac'n conc2ete

Cagna
Some dS foz cemeht capngrete-

finisbikg-
i specefied he _epas.edSunfane shall
he plosted uith 1:3 cement sand maztag nat
ezLeedina smm (Ya,Thickness k he plastenirq
shall he apdlied immendiectly

mencpmehi
paeaSluamenishal be fokeh Ih Cumltuf#)
foa the inished_gangi khodelud" shalhe made
fo he yaluume ofsteel
 2 Page No.:. 29

Dr. D. Y. Patil Polytechnic Roll No.

6 Damp praof cocLASE 2.5 Cm " ) e.c 1:1 2:3-

Mad eials
Dcump p20at Cauase shall cohs1St of cemeht
COwrse Sand b shohe aagzegcueof 1:1l2 :3
by meaSUalng wih measwaiq P2apozt1On wih
2 pf impeana O2 acco pI00f hy weqhi
afcemeni an othen standard uw cder paoofina
Lompauund (ikq peg bca otcemert) The damp
pIOOt cougse shaull be applied _at the plinth
e ve in hoai2ontal lau e ot 2.5Cm thick ness
he cement Shall he faesh_paatond cemeht
OF stcahdagd speci ficat ion the Sahd shall
be Smm size me stone aagaeg.ate shaul be
hard touah of 20mm si2e.
Mizina
miina shall be dane in masohzy plat foam
p in Sheet izaon taay in paapoz4jon_af :l:3
by medSUaingwlth mea Sluaio hoges he
cement is fizst mized thzoughlyuithuae
paoofino compound tothe 2equzed quandity then
miae dzy with Sand in_pra poztion af l: I/2
niz of cenent shall be miaday mjth stahe.aggza
hal the_papaation h:3 clean wadez then
added slowly to give plasiic mix ofaequized
Conslstehtyy
 Page No..B0..*
Roll No. :..

Dr. D. Y. Patil
Polytechnic

loyina be
h e l e vel
of Hhe plinh shall
of Hhe suaface
lonaitudinallu &s T2ansuas y he to p of
DECKed he
appzaaf_caaase S h l he laid fa0gs of
side foqMS 0T Shutferi
ha of
ick_daunumd
hicknecs shaj
Snoawooden batten oE2:5cm
hoth Sldes to_
be fized paopealy & fizmls on fhe shutteaina
Confine the concaete sohat
does not 4ei distua bad dunira compaetlon &
martas does not leak thaolLo)h the ihnne edges
af shui tea ] ng does naB qet distuabedhe surface
shold clean &uet ha0uah uatezingbeoze-
conczede.laid heconcaele shall laid in iB hauns
com pacted ba tamping to -pmake clonge conczee_
leveled both lenqitudinally +nunsveasely
af tes tuao hauas of lay ina concaeie shall make
a0ugh chequred o as to fozrna key uwith umall
abave

Cualkha
fhe damp proof cauase shall be Cuaed
o abezing kep uct fon 7days fhe
susface shal be clean ettedbefoze mdsanzy
i sstanted
9ca Damp pzAAf couse
he daump pzoof counse may be df 2cm
(3/ thic k lCe af T:2cement coarse Sah d
moziar withsiandaad ure pa00fina campound..
 Page No.31..
Dr. D. Y. Patil Polytechnic Roll No.

Baick ao2k I class

Baicks
of standund
A baicks shall be_of fiasl class
Speijcation m0d e of qand baick eas th thzoahl
Ted a
buant be aequlr in shape cheazy
C.oppe Caloua Bzick shaull be 2equlia in shape
Shau Emit
hetz edaes should be shap k
stauckLShall
clec Ian ina Sauh d on bina
lunps
be fzee faom caaks Chips f laws
o t any kind Bzick shallnoi abSon
b wtea
thelz weiqhd caushina
moae hun ohe sizth ot J

strengh loS kapez Sq m_

Mazt aa
speitied kmateaius af
Mogtaa shall be
to shall be of siCuhd ad SpecEication
ma
fpa_cement mastag
cemehd shall be faesb
cement of sBcandand spe.cificatlon.
poatland aaanic
cleauh k tree fzom
S.ad Shall be Shazp ma1taa_coanse
fageqin maites foa aich
weuk
sand should be used k fea
mediym
localLPine [und moLy
be used paapaatlan
magtaq
motaa mcLy be
of : 3 fo l.6
Ofcement scnd
Mateglalg at
maatan shall be
asspecEied
hae the 2eqwzed paapoztian_
meaSuaed to Sand
measualna boz & fizst mized dzy
wih lean masonzy platha2m
wnifoam_colouain
to heuue waea Slauly-
cLddlna clean
Lhen i 2ed_by
 PageN o . : . 2 . .

Roll No. . .

Dr. D. Y. Patil Polytechnic

Saakina af baick- cleoun uwuta

Brick shal be fully- soak ed in clecn
eaiod
ySubmenging ing alan k fana p
of 2 haua S immediatey befoz UJse

layig
Baick ahall he wel bondehd_& lald inengi's
band Unle ssothea u's e 5pecified coaase shall
befauly hoaiqzontculy & wli shal be taluly
in plunmh venticaljaints of consecative coumse
shall hot comediaeo/y ores ohe an ofh
yetical Joini in a teanate cause shallbe.
a t cleauh Cud bnick shall be placed neaa endd
o f wls bu hat at ather edae mgataa
oint shall hat exceed Gmml /u")ih thicknes
join fuullyfillel with moata

the baickuo0zk shal be kept ue foz a peaiod

of uleast ladous aftea laujna A4 the e hd
afda's uioa k the tops of wall shall be tbad ed
uith aeqt04 usater by makjna shaall
ueak aa taa
edgiha to contain at leagt 2Sch C) do p

Protecding
The baickuozk shallbe p
2otgcted Fzon
h e e ffeci of
sunaain.faasietcdualm
h e constaucted of bzick & ig
upto such fime
 Page No...3..

Dr. D. Y. Patil Polytechnic Roll No. * * *

15g1eeh &liKely to be douma -ed

Scas faldiha- be
& suitahle scaffalding shal l
Necessaay
theonstuctloh 0F
PTavidd to fcclitade
baick ulLscafald i'ng shau be s Dnd&iently
membens Suffic
Staona& supp01tS

S6rick_ungk 2"d 3 class

baick uwozkhoick shal be af

fa7 2 class
shall he specikiedes baq4
Secad class &_ma ztaa
Kan ka line 6x white lime Suakj loz
he
oTcindez of 1:2 to l:3 PaapoatDh
Sand
Shall_nai e.ceed lomm[ 3"
moztaa joainds socked ih waten
shallhe
in thickness Baick
hoursS
foa atleas thaee
wonkshall be 37d c
lass
baick
faz 22dclass cified moataa shaul/
be
noi spe ezceal
i f otmeMuise Jaintsshall no t
mozta
As s0ecified thickhess. Baick
should he
nmm (S14 in
iuh Of wadea hefoz use-
dipped m toa
 Page No...

Roll No.
Dr. D. Y. Patil Polytechnic

m0ztam
9H Plasteaina lime
cemen mogicia 07 he Taked
shallbe zaked
baick ta0rk
Ihe joind of the suztace
Out lodeapth of Smm (3).L the
shallbe wgshed put kept uwet
Otthe wall
foa two days befoe plastenig
0z
The mateniau af moataa cement sand
ime Suakhi oa Sand o Kankaa lime_,05
specifiedshould he of standaad specificalinn_
The matealal az moaio Shll be £iastdaz
mized by measalnq with bo2es to haue
the requwTed paapoation uatea cdded
hzaughly
he thickhess_of plasteainq Sall be cs
specified usually 12mm )applied in tuo
aathaee Cocts to toenslne uhifoam
thicknessofplastea,batches ot l5cm LGcml
stip l0.cmlH)_oz() mide.plastez shall
beappllied fizst at aboud 2 m apand to act
asquide inst mo2ian shall be dashed
pmessedovea the suatace heh baouahi to
taue smoath unitoam_sunka.ce by_meah
fflaal trouwe.eaten nal plasBeaina shallbe
s taated foam iop_ o2 ked dowh Tawands
floo Indenha) plaskezing shalhe Stoate
whetever the buildiq iaome is zeady
cendegina of the 200t Slabs hawe_ beeh
fon ideal uwork he plastenih shauld he
o pplied in three coats- the zehdehina of
appliedin
loatirg seand Caad
coa afE lomm the floatim oz0g seand fizst
coat of
 3S Page No...3.5..
Dr. D. Y. Patil Polytechnic Roll No. .

1omm to Gmm finis hina_co.at of 5to6mm

hauihaa total minimun thickn.es S 0f 2omm
(3/4") Hhe fnstcoad of be applied on the
paepaed aaded ee cleahed & wel ted suafare
b dashi ha the moata floating oua hly
with wood eh flod iE shall he kept damp
fazallea St two.dausheh the fizsi coat
has sufficiehdly se the Suaface Shollbe
wetted asecahd coad of plasten shol
be_applied & baoua hd to even tzlle sumtace
hehliahtly 2ouaheh ed with o0.0deh float
pJ0Vlde bond foa the finished coaiL

Cuaing
Cuaina shalll be staates as SOan as the
plasler has hmckned safficien)ly_nai to be
damaqed hen wateaed.

10 Painiina cemeni oa lime mogton

The oint gf the baick uog k shall he aated
Out toa depth of 20 mm(3")8 he sudtace
of the wall pashed out cleaned &Kept
we Fo1 twodays
The mateaiols of moataa cemehi&saand
orlime suakhi og scLnd 07 Kan Kaua ime
specificalia
CS 3pecifiedshall be of stand asd
the mabezial _mgzBaa shall be first dzy
mized by medSuAInawith bomes to have Hhe
Iequzed p7ap07tion aS specfied
C:2 0z l:3)
 PageNo..96
Roll No. ....

Dr. D. Y. Patil Polytechnic

Suakhi_mgztaz
moatua for lime
foxcement scund
mimed by adding uates

Flush pointig-
hall be _pnessed/nto Hhe 2ated
The maatto s
finish ed off
eleaned uet Onts shall be
flush level uith edaes_gf haick f0 give
smoot appeauncy

Ruled poainting
Themartan shall be paesSed into the
2ahedcleched kwet oin k aqzoove Ot
s hapel size of 5 toGmm deep 5hall be Poamed
unhi, a foaming toof_0f s-tal steel alona the
Centea ine af Jaint
ectmea oT LCK pintio9
Ihe montan shall be applied on the 7aKed
clened buet joint &hnizontal oint shall_
be_paessed finished uitaa-pajndinq tool_
Rusedor taucked paintinq-
The magt shall be
applied in ruke d ckan ed
wet oints in emcesS fri
Lthe moata s hall fo-qmFaised bends
+ool toform band bePzesse& pun toith pzo ner