SAFETY DATA SHEET

Sullair AWF
Prepared according to U.S. OSHA, CMA, ANSI, Canadian WHMIS, Australian WorkSafe, Japanese Industrial Standard JIS Z 7250:2000, and European Union REACH Regulations

SECTION 1 - PRODUCT AND COMPANY IDENTIFICATION

Includes:
PRODUCT NAME: Sullair AWF Sullair AWF250025 266
CAS#: Mixture Sullair AWF250030 758
Sullair AWF 250030 757
SUPPLIER/MANUFACTURER'S NAME: D-A Lubricant Company, Inc. Sullair AWF02250098 040
ADDRESS: 801 Edwards Drive, Lebanon, IN 46052 USA
EMERGENCY PHONE: TOLL-FREE in USA/Canada 800-899-9004
BUSINESS PHONE: 317-923-5321 (Product Information)
WEB SITE: www.dalube.com
DATE OF PREPARATION: November 8, 2011
DATE OF LAST REVISION: April 9, 2013

SECTION 2 - HAZARDS IDENTIFICATION

EMERGENCY OVERVIEW: This product is amber liquid with a mild petroleum hydrocarbon odor.
HEALTH HAZARDS: Low order of toxicity. Excessive exposure may result in eye, skin and respiratory irritation.
FLAMMABILITY: This product is not classified as a flammable liquid. Flashpoint: >185°C (>365°F)
ENVIRONMENTAL EFFECTS: The Environmental effects of this product have not been investigated. Floats on water.
If it enters soil, it will be absorbed to soil particles and will not be mobile. This product may cause gastrointestinal
distress in birds and mammals through ingestion during pelage grooming.
US DOT SYMBOLS CANADA (WHMIS) SYMBOLS EUROPEAN and (GHS) Hazard Symbols

Non-Regulated Not Controlled

Signal Word: Warning!

EU LABELING AND CLASSIFICATION:
Classification of the substance or mixture according to Regulation (EC) No1272/2008 Annex 1
EC# 276-735-8 This substance is not classified in the Annex I of Directive 67/548/EEC
EC# 265-161-3 This substance is not classified in the Annex I of Directive 67/548/EEC
Methacrylate Copolymer is exempt from listing
EC# 272-028-3 This substance is not classified in the Annex I of Directive 67/548/EEC
GHSHazardClassification(s):
None
HazardStatement(s): PrecautionaryStatement(s):
H320: Causes eye irritation P260: Do not breath dust/fume/gas/mist/vapors/spray
H315: Causes skin irritation P264: Wash hands thoroughly after handling
H332: Harmful if inhaled P271: Use only in well ventilated area.
H335: May cause respiratory irritation P280: Wear protective gloves/protective clothing/eye
protection/face protection
EU HAZARD CLASSIFICATION PER DIRECTIVE 1999/45/EC:
[Xi] Irritant
RiskPhrases: SafetyPhrases:
R36/37/38: Irritating to eyes, respiratory system and skin S24/25: Avoid contact with skin and eyes
S36: Wear suitable protective clothing
S37/39: Wear suitable gloves and eye/face protection
S45: In case of accident or if you feel unwell, seek medical
advice immediately.
HEALTH HAZARDS OR RISKS FROM EXPOSURE:
ACUTE:
EYE: Contact may cause mild irritation including stinging, watering and redness.
SKIN: Prolonged contact may cause mild skin irritation. No harmful effects from skin absorption are expected.
 SAFETY DATA SHEET
Sullair AWF
INHALATION: Breathing vapors or fumes may cause respiratory irritation.
INGESTION: Ingestion may cause irritation of the digestive tract, nausea, vomiting and diarrhea.
CHRONIC: None known
TARGET ORGANS: ACUTE: Eye, Respiratory System, Skin CHRONIC: None known

SECTION 3 - COMPOSITION and INFORMATION ON INGREDIENTS

HAZARD CLASSIFICATION;
HAZARDOUS INGREDIENTS: CAS # EINECS # ICSC # WT %
RISK PHRASES
72623-83-7 276-735-8 HAZARD CLASSIFICATION: [Xi] Irritant
Highly Refined Base Stock Oil Not Listed <90%
64742-58-1 265-161-3 RISK PHRASES: R36/37/38
Exempt from HAZARD CLASSIFICATION: None
Methacrylate Copolymer Not Assigned Not Listed <8%
listing RISK PHRASES: None
HAZARD CLASSIFICATION: None
Zinc Alkyl Dithiophosphate 68649-42-3 272-028-3 Not Listed <2%
RISK PHRASES: None
Balance of other ingredients are non-hazardous or less than 1% in concentration (or 0.1% for
carcinogens, reproductive toxins, or respiratory sensitizers).

NOTE: ALL WHMIS required information is included in appropriate sections based on the ANSI Z400.1-2004 format. This product has been classified
in accordance with the hazard criteria of the CPR and the MSDS contains all the information required by the CPR, EU Directives and the
Japanese Industrial Standard JIS Z 7250: 2000.

SECTION 4 - FIRST-AID MEASURES

Contaminated individuals of chemical exposure must be taken for medical attention if any adverse effect occurs.
Rescuers should be taken for medical attention, if necessary. Take copy of label, bill of lading and/or MSDS to health
professional with contaminated individual.
EYE CONTACT: If product enters the eyes, open eyes while under gentle running water for at least 15 minutes. Remove
contact lenses if worn. Seek medical attention if irritation persists.
SKIN CONTACT: W ash skin thoroughly after handling. Seek medical attention if irritation develops and persists. Remove
contaminated clothing. Launder before re-use.
INHALATION: If breathing becomes difficult, remove victim to fresh air. If necessary, use artificial respiration to support
vital functions. Seek medical attention if breathing difficulty continues.
INGESTION: If product is swallowed, call physician or poison control center for most current information. If professional
advice is not available, do not induce vomiting. Never induce vomiting or give diluents (milk or water) to someone who is
unconscious, having convulsions, or who cannot swallow. Seek medical advice. Take a copy of the label and/or MSDS
with the victim to the health professional.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: Pre-existing skin, respiratory system or eye problems may be
aggravated by prolonged contact.
RECOMMENDATIONS TO PHYSICIANS: Treat symptoms and reduce over-exposure.

SECTION 5 - FIRE-FIGHTING MEASURES

FLASH POINT: >185ºC (>365°F) ASTM D-92
AUTOIGNITION TEMPERATURE: Not Established
FLAMMABLE LIMITS (in air by volume, %): Lower (LEL): Not Available Upper (UEL): Not Available
FIRE EXTINGUISHING MATERIALS: Use water fog, foam, dry chemical or carbon dioxide (CO2) to
extinguish flames.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Do not use straight streams of water. This product is a combustible
liquid at temperatures above flash point.
Explosion Sensitivity to Mechanical Impact: Not Sensitive.
Explosion Sensitivity to Static Discharge: Sensitive
SPECIAL FIRE-FIGHTING PROCEDURES: Incipient fire responders should wear eye protection. Structural
firefighters must wear Self-Contained Breathing Apparatus and full
protective equipment. Isolate materials not yet involved in the fire and
protect personnel. Move containers from fire area if this can be done
Page 2 of 6
 SAFETY DATA SHEET
Sullair AWF
without risk; otherwise, cool with carefully applied water spray. If
possible, prevent runoff water from entering storm drains, bodies of
water, or other environmentally sensitive areas.
NFPA RATING SYSTEM HMIS RATING SYSTEM
HAZARDOUS MATERIAL IDENTIFICATION SYSTEM
Flammability
HEALTH HAZARD (BLUE) 1

FLAMMABILITY HAZARD (RED) 1

1
Health Reactivity
1 0 PHYSICAL HAZARD (YELLOW) 0
-
PROTECTIVE EQUIPMENT
EYES RESPIRATORY HANDS BODY
Other
See
See Sect 8
Sect 8

For Routine Industrial Use and Handling Applications

Hazard Scale: 0 = Minimal 1 = Slight 2 = Moderate 3 = Serious 4 = Severe * = Chronic hazard

SECTION 6 - ACCIDENTAL RELEASE MEASURES

SPILLANDLEAKRESPONSE: Personnel should be trained for spill response operations.
SPILLS: Contain spill if safe to do so. Prevent entry into drains, sewers, and other waterways. Soak up with an absorbent material and
place in an appropriate container for disposal. Dispose of in accordance with applicable Federal, State, and local procedures (see
Section 13, Disposal Considerations).
If spill of any amount is made into or upon navigable waters, the contiguous zone or adjoining shorelines, notify the
National Response Center (phone number 800-424-8802).
Dispose of in accordance with applicable Federal, State, and local procedures (see Section 13, Disposal Considerations).

SECTION 7 - HANDLING and STORAGE

WORK PRACTICES AND HYGIENE PRACTICES: As with all chemicals, avoid getting this product ON YOU or IN YOU.
Wash thoroughly after handling this product. Do not eat, drink, smoke, or apply cosmetics while handling this product.
Avoid breathing vapors/mists generated by this product. Use in a well-ventilated location. Remove contaminated clothing
immediately.

STORAGE AND HANDLING PRACTICES: Containers of this product must be properly labeled. Store containers in a
cool, dry location. Keep container tightly closed when not in use. Do not store at temperatures above 120°F (49°C) Store
away from strong oxidizers. Empty containers retain residue and can be dangerous. DO NOT pressurize, cut weld, braze,
solder, drill, grind, or expose such containers to heat, flame, sparks, or other ignition sources; they may explode and
cause injury.

SECTION 8 - EXPOSURE CONTROLS - PERSONAL PROTECTION

EXPOSURELIMITS/GUIDELINES:

Chemical Name CAS# ACGIH TWA OSHA TWA SWA

Highly Refined Base Stock 72623-83-7 5 mg/m³ Oil Mist 5 mg/m³ Oil Mist 5 mg/m³ Oil Mist
Oil 64742-58-1
Methacrylate Copolymer Not Assigned Not Listed Not Listed Not Listed

Zinc Alkyl Dithiophosphate 68649-42-3 Not Listed Not Listed Not Listed

Currently, International exposure limits are not established for the components of this product. Please check with
competent authority in each country for the most recent limits in place.

Page 3 of 6
 SAFETY DATA SHEET
Sullair AWF
VENTILATION AND ENGINEERING CONTROLS: Use with adequate ventilation to ensure exposure levels are
maintained below the limits provided above. Use local exhaust ventilation to control airborne vapor. Ensure
eyewash/safety shower stations are available near areas where this product is used.
The following information on appropriate Personal Protective Equipment is provided to assist employers in complying
with OSHA regulations found in 29 CFR Subpart I (beginning at 1910.132) or equivalent standard of Canada, or
standards of EU member states (including EN 149 for respiratory PPE, and EN 166 for face/eye protection), and those
of Japan. Please reference applicable regulations and standards for relevant details.
RESPIRATORY PROTECTION: Not normally required. Maintain airborne contaminant concentrations below guidelines
listed above, if applicable. If necessary, use only respiratory protection authorized in the U.S. Federal OSHA Respiratory
Protection Standard (29 CFR 1910.134), equivalent U.S. State standards, Canadian CSA Standard Z94.4-93, the
European Standard EN149, or EU member states.
EYE PROTECTION: Safety glasses or chemical goggles as appropriate to prevent eye contact. If necessary, refer to
U.S. OSHA 29 CFR 1910.133 or appropriate Canadian Standards.
HAND PROTECTION: Use chemical resistant gloves to prevent skin contact. If necessary, refer to U.S. OSHA 29 CFR
1910.138 or appropriate Standards of Canada.
BODY PROTECTION: Use body protection appropriate to prevent contact (e.g. lab coat, overalls). If necessary, refer to
appropriate Standards of Canada, or appropriate Standards of the EU, Australian Standards, or relevant Japanese
Standards.

SECTION 9 - PHYSICAL and CHEMICAL PROPERTIES

PHYSICAL STATE: Liquid
APPEARANCE & ODOR: Amber color with petroleum hydrocarbon odor.
ODOR THRESHOLD (PPM): Mild
VAPOR PRESSURE (mmHg): <0.013 kPa (0.1 mm Hg) at 20°C
VAPOR DENSITY (AIR=1): No Data Available.
EVAPORATION RATE (nBuAc = 1): No Data Available
BOILING POINT (C°): >500°F (>260°C)
FREEZING POINT (C°): No Data Available
pH: Not Applicable
SPECIFIC GRAVITY 20°C: (WATER =1) 0.87 @60°F
SOLUBILITY IN WATER (%) Negligible
VISCOSITY @ 100°C cSt 6.95

SECTION 10 - STABILITY and REACTIVITY

STABILITY: Product is stable
DECOMPOSITION PRODUCTS: material does not decompose under normal storage conditions. When heated to
decomposition this product produces carbon dioxide and carbon monoxide.
MATERIALS WITH WHICH SUBSTANCE IS INCOMPATIBLE: Strong oxidizers
HAZARDOUS POLYMERIZATION: W ill not occur.
CONDITIONS TO AVOID: Contact with incompatible materials. Excessive heat and high energy sources of ignition.

SECTION 11 - TOXICOLOGICAL INFORMATION

TOXICITY DATA: Toxicity data is not available for mixture:
CAS# 72623-83-7, 64742-58-1
Acute Oral Toxicity LD50 >5,000 mg/kg Rat
Acute Dermal Toxicity LD50 >5,000 mg/kg Rat

SUSPECTED CANCER AGENT: This product may contain an ingredient(s) that is found on one or more of the following
lists: FEDERAL OSHA Z LIST, NTP, CAL/OSHA, IARC and therefore is considered to be, or suspected to be a
cancer-causing agent by these agencies.
IRRITANCY OF PRODUCT: Contact with this product can be irritating to exposed skin, eyes and respiratory system.
Page 4 of 6
 SAFETY DATA SHEET
Sullair AWF
REPRODUCTIVE TOXICITY INFORMATION: No information concerning the effects of this product and its components
on the human reproductive system.
ADDITIONAL INFORMATION: Use oils may contain harmful impurities that have accumulated during use. The
concentration of such impurities will depend on use and they may present risks to health and the environment on
disposal.

SECTION 12 - ECOLOGICAL INFORMATION

ALL WORK PRACTICES MUST BE AIMED AT ELIMINATING ENVIRONMENTAL CONTAMINATION.
ENVIRONMENTAL STABILITY: Liquid under most environmental conditions. Floats on water. If it enters soil, it will
adsorb to soil particles and will not be mobile.
EFFECT OF MATERIAL ON PLANTS or ANIMALS: If applied to leaves, this product may kill grasses and small plants
by interfering with transpiration and respiration. This product is not toxic to fish but may coat gill structures resulting in
suffocation if spilled in shallow, running water. Product may be moderately toxic to amphibians by preventing dermal
respiration. This product may cause gastrointestinal distress in birds and mammals through ingestion during pelage
grooming.
EFFECT OF CHEMICAL ON AQUATIC LIFE: No evidence is currently available on this product’s effects on aquatic life.

SECTION 13 - DISPOSAL CONSIDERATIONS

PREPARING WASTES FOR DISPOSAL: Recover or recycle if possible. It is the responsibility of the waste generator to
determine the toxicity and physical properties of the material generated to determine the proper waste classification and
disposal methods in compliance with applicable regulations. Do not dispose into the environment, in drains, or in water
courses. W aste disposal must be in accordance with appropriate Federal, State, and local regulations, those of
Canada, Australia, EU Member States and Japan.
Container disposal should be done in accordance with prevailing regulations, preferably to a recognized collector or
contractor.

SECTION 14 - TRANSPORTATION INFORMATION

USDOT;IATA;IMO;ADR:
THIS PRODUCT IS NOT HAZARDOUS AS DEFINED BY 49 CFR 172.101 BY THE U.S. DEPARTMENT OF TRANSPORTATION.
PROPER SHIPPING NAME: Non-Regulated Material
HAZARD CLASS NUMBER and DESCRIPTION: : None
UN IDENTIFICATION NUMBER: None
PACKING GROUP: None
DOT LABEL(S) REQUIRED: None
NORTH AMERICAN EMERGENCY RESPONSE GUIDEBOOK NUMBER (2004): None
MARINE POLLUTANT: None of the ingredients are classified by the DOT as a Marine Pollutant (as defined by 49
CFR 172.101, Appendix B)
U.S. DEPARTMENT OF TRANSPORTATION (DOT) SHIPPING REGULATIONS:
This product is not classified as dangerous goods, per U.S. DOT regulations, under 49 CFR 172.101.
TRANSPORT CANADA, TRANSPORTATION OF DANGEROUS GOODS REGULATIONS:
This product is not classified as Dangerous Goods, per regulations of Transport Canada.
INTERNATIONAL AIR TRANSPORT ASSOCIATION (IATA):
This product is not classified as Dangerous Goods, by rules of IATA:
INTERNATIONAL MARITIME ORGANIZATION (IMO) DESIGNATION:
This product is not classified as Dangerous Goods by the International Maritime Organization.
EUROPEAN AGREEMENT CONCERNING THE INTERNATIONAL CARRIAGE OF DANGEROUS GOODS BY ROAD (ADR):
This product is not classified by the United Nations Economic Commission for Europe to be dangerous goods.

SECTION 15 - REGULATORY INFORMATION

UNITEDSTATESREGULATIONS
SARA REPORTING REQUIREMENTS: This product is not subject to the reporting requirements of Sections 302, 304 and 313 of
Title III of the Superfund Amendments and Reauthorization Act., as follows: SARA 313 Reporting Zinc Alkyl Dithiophosphate
CAS# 68649-42-3 <2%
Page 5 of 6
 SAFETY DATA SHEET
Sullair AWF
TSCA: All components in this product are listed on the US Toxic Substances Control Act (TSCA) inventory of chemicals.
SARA311/312:
Acute Health: Yes Chronic Health: No Fire: No Reactivity: No

U.S. SARA THRESHOLD PLANNING QUANTITY: There are no specific Threshold Planning Quantities for this product. The
default Federal MSDS submission and inventory requirement filing threshold of 10,000 lb (4,540 kg) may apply, per 40 CFR
370.20.
U.S.CERCLAREPORTABLEQUANTITY(RQ): None
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT (PROPOSITION 65): This product does not contain
ingredient(s) which are on the California Proposition 65 lists.
CANADIANREGULATIONS:
CANADIAN DSL/NDSL INVENTORY STATUS: All of the components of this product are on the DSL Inventory
CANADIAN ENVIRONMENTAL PROTECTION ACT (CEPA) PRIORITIES SUBSTANCES LISTS: No component of this product is
on the CEPA First Priorities Substance Lists.
CANADIAN WHMIS CLASSIFICATION and SYMBOLS: This product is categorized as Not Controlled, as per the Controlled
Product Regulations
EUROPEANECONOMICCOMMUNITYINFORMATION:
EU LABELING AND CLASSIFICATION:
Classification of the mixture according to Regulation (EC) No1272/2008. See section 2 for details.
AUSTRALIANINFORMATIONFORPRODUCT:
AUSTRALIAN INVENTORY OF CHEMICAL SUBSTANCES (AICS) STATUS: All components of this product are listed or exempt on
the AICS.
STANDARD FOR THE UNIFORM SCHEDULING OF DRUGS AND POISONS: Not applicable.
JAPANESEINFORMATIONFORPRODUCT:
JAPANESE MINISTER OF INTERNATIONAL TRADE AND INDUSTRY (MITI) STATUS: The components of this product are not
listed as Class I Specified Chemical Substances, Class II Specified Chemical Substances, or Designated Chemical Substances by
the Japanese MITI.

INTERNATIONALCHEMICALINVENTORIES:
Listing of the components on individual country Chemical Inventories is as follows:
Asia-Pac: Listed or Exempt
Australian Inventory of Chemical Substances (AICS): Listed or Exempt
Korean Existing Chemicals List (ECL): Listed or Exempt
Japanese Existing National Inventory of Chemical Substances (ENCS): Listed or Exempt
Philippines Inventory if Chemicals and Chemical Substances (PICCS): Listed or Exempt
Swiss Giftliste List of Toxic Substances: Listed or Exempt
U.S. TSCA: Listed or Exempt

SECTION 16 - OTHER INFORMATION

Disclaimer: The information in this document is believed to be correct as of the date issued. HOWEVER, NO
WARRANTY OF MERCHANTABILITY, FITNESS FOR ANY PARTICULAR PURPOSE, OR ANY OTHER
WARRANTY IS EXPRESSED OR IS TO BE IMPLIED REGARDING THE ACCURACY OR COMPLETENESS OF
THIS INFORMATION, THE RESULTS TO BE OBTAINED FROM THE USE OF THIS INFORMATION OR THE
PRODUCT, THE SAFETY OF THIS PRODUCT, OR THE HAZARDS RELATED TO ITS USE. This information and
product are furnished on the condition that the person receiving them shall make his own determination as to the
suitability of the product for his particular purpose and on the condition that he assume the risk of his use thereof.

Page 6 of 6