SAFETY DATA SHEET

ROYCO 555 DOD-PRF-85734

Version: 1.2 Revision Date: 01/30/2015 Print Date: 04/22/2015

SECTION 1. PRODUCT AND COMPANY IDENTIFICATION

Product name: ROYCO 555 DOD-PRF-85734

TURBINE ENGINE & HELICOPTER TRANSMISSION OIL

Product Use Description: Lubricant

Company:

Manufacturer
Anderol Specialty Lubricants, a division of Chemtura Corporation
215 Merry Lane
East Hanover, NJ
07936
United States of America

Telephone: +1 203-573-4596, Toll Free: +1 888-263-3765

Email: [email protected]
Emergency telephone CHEMTREC: (24 hours) 800-424-9300
number: :
Chemtura Corporation Emergency Response: CHEMTURA : 800-292-5898

For additional emergency telephone numbers see section 16 of the Safety

Data Sheet.

Prepared by Product Safety Department

(US) +1 866-430-2775

[email protected]

Recommended use of the chemical and restrictions on use

Recommended use : Lubricant

SECTION 2. HAZARDS IDENTIFICATION

Form liquid
Colour amber
Odour mild

GHS Classification
Reproductive toxicity : Category 2
Acute aquatic toxicity : Category 3
Chronic aquatic toxicity : Category 3
SAP 6.0 SDS 2012-2 NA GHS 1 / 10 SDS Number: 400000001740
 SAFETY DATA SHEET

ROYCO 555 DOD-PRF-85734

Version: 1.2 Revision Date: 01/30/2015 Print Date: 04/22/2015

GHS Label element

Signal word : Warning

Hazard pictograms :

Hazard statements : H361 Suspected of damaging fertility or the unborn child.

H412 Harmful to aquatic life with long lasting effects.

Other hazards : None

Precautionary statements : Prevention:

P201 Obtain special instructions before use.
P202 Do not handle until all safety precautions have been read
and understood.
P273 Avoid release to the environment.
P281 Use personal protective equipment as required.
Response:
P308 + P313 IF exposed or concerned: Get medical advice/
attention.
Storage:
P405 Store locked up.
Disposal:
P501 Dispose of contents/ container to an approved waste
disposal plant.

Carcinogenicity:
IARC No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
OSHA No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
NTP No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.

SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS

Hazardous components

Chemical Name CAS-No. Concentration (%)

SAP 6.0 SDS 2012-2 NA GHS 2 / 10 SDS Number: 400000001740

 SAFETY DATA SHEET

ROYCO 555 DOD-PRF-85734

Version: 1.2 Revision Date: 01/30/2015 Print Date: 04/22/2015

Fatty acids, C5-9, tetraesters with pentaerythritol 67762-53-2 >= 70 - < 90 %

Fatty acids, C5-9, hexaesters with dipentaerythritol 67762-52-1 >= 5 - < 10 %
NJTS-46728100000-0001 >= 1 - < 5 %
tris(methylphenyl) phosphate 1330-78-5 >= 0.1 - < 1 %

SECTION 4. FIRST AID MEASURES

If inhaled : If inhaled
Move to fresh air.
If not breathing, give artificial respiration.
If breathing is difficult, give oxygen.
In case of bluish discolouration (lips, ear lobes, fingernails),
give oxygen as quickly as possible.
If symptoms persist, call a physician.

In case of skin contact : In case of skin contact

Wash off with soap and water.
Remove contaminated clothing and shoes.
Wash contaminated clothing before re-use.
Get medical attention if irritation develops and persists.

In case of eye contact : In case of eye contact

Rinse thoroughly with plenty of water, also under the eyelids.
If eye irritation persists, consult a specialist.

If swallowed : If swallowed, DO NOT induce vomiting.

Consult a physician if necessary.

Most important symptoms : None known.

and effects, both acute and
delayed
Notes to physician : For specialist advice physicians should contact the Poisons
Information Service.

SECTION 5. FIREFIGHTING MEASURES

Suitable extinguishing media : Carbon dioxide (CO2)

Dry powder
Foam
Alcohol-resistant foam
Water mist

Unsuitable extinguishing : High volume water jet

media

Specific hazards during : Burning produces noxious and toxic fumes.

firefighting

Specific extinguishing : In the event of fire, cool tanks with water spray.
methods
SAP 6.0 SDS 2012-2 NA GHS 3 / 10 SDS Number: 400000001740
 SAFETY DATA SHEET

ROYCO 555 DOD-PRF-85734

Version: 1.2 Revision Date: 01/30/2015 Print Date: 04/22/2015

Special protective equipment : In the event of fire, wear self-contained breathing apparatus.
for firefighters Use personal protective equipment.

SECTION 6. ACCIDENTAL RELEASE MEASURES

Personal precautions, : Use personal protective equipment.

protective equipment and Ensure adequate ventilation.
emergency procedures

Environmental precautions : Should not be released into the environment.

Do not contaminate water.
Do not flush into surface water or sanitary sewer system.

Methods and materials for : Contain spillage, soak up with non-combustible absorbent
containment and cleaning up material, (e.g. sand, earth, diatomaceous earth, vermiculite)
and transfer to a container for disposal according to local /
national regulations (see section 13).

SECTION 7. HANDLING AND STORAGE

Advice on safe handling : Keep container closed when not in use.

Do not use pressure to empty drums.
Ensure all equipment is electrically grounded before beginning
transfer operations.

Conditions for safe storage : Keep container tightly closed in a dry and well-ventilated
place.

Materials to avoid : Strong acids and strong bases

SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION

Components with workplace control parameters

Engineering measures : Effective exhaust ventilation system

Ensure that eyewash stations and safety showers are close to
the workstation location.

Personal protective equipment

Respiratory protection : Breathing apparatus needed only when aerosol or mist is
formed.
In the case of vapour formation use a respirator with an
approved filter.

Hand protection
Remarks : Neoprene gloves

SAP 6.0 SDS 2012-2 NA GHS 4 / 10 SDS Number: 400000001740

 SAFETY DATA SHEET

ROYCO 555 DOD-PRF-85734

Version: 1.2 Revision Date: 01/30/2015 Print Date: 04/22/2015

Eye protection : Safety glasses with side-shields

Tightly fitting safety goggles

Skin and body protection : impervious clothing

Hygiene measures : Avoid contact with skin, eyes and clothing.

Handle in accordance with good industrial hygiene and safety
practice.
Wash hands before breaks and at the end of workday.

SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES

Appearance : liquid

Color : amber
Odor : mild
Odour Threshold : No data available
pH : No data available
Melting point/range :
Not applicable
Boiling point/boiling range : No data available
Evaporation rate : No data available
Flash point : > 246 °C
Method: ASTM D92

Upper explosion limit : No data available

Lower explosion limit : No data available
Vapour pressure : No data available
Relative vapour density : No data available
Relative density : 0.99
Density : No data available
Solubility(ies)
Water solubility : slightly soluble
Solubility in other solvents : No data available

Partition coefficient: n- : No data available

octanol/water
Auto-ignition temperature : No data available
Thermal decomposition : No data available

Viscosity
Viscosity, kinematic : No data available

SAP 6.0 SDS 2012-2 NA GHS 5 / 10 SDS Number: 400000001740

 SAFETY DATA SHEET

ROYCO 555 DOD-PRF-85734

Version: 1.2 Revision Date: 01/30/2015 Print Date: 04/22/2015

SECTION 10. STABILITY AND REACTIVITY

Reactivity : No dangerous reaction known under conditions of normal use.

Chemical stability : Stable under normal conditions.

Possibility of hazardous : Hazardous polymerisation does not occur.

reactions
Conditions to avoid : Contamination
Heat, flames and sparks.

Incompatible materials : Strong acids and strong bases

Hazardous decomposition :
products Carbon oxides

SECTION 11. TOXICOLOGICAL INFORMATION

Acute oral toxicity (Product) : Acute toxicity estimate: > 5,000 mg/kg

Method: Calculation method

Acute dermal toxicity

NJTS-46728100000-0001 : LD50: > 2,000 mg/kg
(Component) Species: Rat

Skin irritation
NJTS-46728100000-0001 : Species: Rabbit
(Component) Result: No skin irritation
Method: OECD Test Guideline 404

Eye irritation
NJTS-46728100000-0001 : Species: Rabbit
(Component) Result: No eye irritation
Method: OECD Test Guideline 405

Sensitisation
NJTS-46728100000-0001 : Species: Guinea pig
(Component) Classification: Did not cause sensitisation on laboratory animals.
Method: OECD Test Guideline 406

Aspiration toxicity (Product) : No aspiration toxicity classification

SAP 6.0 SDS 2012-2 NA GHS 6 / 10 SDS Number: 400000001740

 SAFETY DATA SHEET

ROYCO 555 DOD-PRF-85734

Version: 1.2 Revision Date: 01/30/2015 Print Date: 04/22/2015

CMR effects
Fatty acids, C5-9, tetraesters : Mutagenicity: Animal testing did not show any mutagenic effects.
with pentaerythritol Teratogenicity: No effects on or via lactation
(Component) Reproductive toxicity: No toxicity to reproduction

NJTS-46728100000-0001 : Mutagenicity: Not mutagenic in Ames Test.

(Component)
tris(methylphenyl) phosphate : Carcinogenicity: Animal testing did not show any carcinogenic effects.
(Component) Mutagenicity: In vitro tests did not show mutagenic effects
Teratogenicity: Did not show teratogenic effects in animal experiments.
Reproductive toxicity: Suspected of damaging fertility or the unborn
child.

Further information (Product) : There is no data available for this product.

SECTION 12. ECOLOGICAL INFORMATION

Ecotoxicity effects

Toxicity to fish (Product) : Remarks:

No data available

Toxicity to daphnia and other : Remarks:

aquatic invertebrates No data available
(Product)

Toxicity to algae (Product) : Remarks:

No data available

Toxicity to bacteria
tris(methylphenyl) phosphate : EC50: > 100 mg/l
(Component) Exposure time: 3 h
Species: activated sludge
Respiration inhibition

Elimination information (persistence and degradability)

Bioaccumulation (Product) : Remarks:

No data available

Mobility (Product) : Remarks:

No data available

SAP 6.0 SDS 2012-2 NA GHS 7 / 10 SDS Number: 400000001740

 SAFETY DATA SHEET

ROYCO 555 DOD-PRF-85734

Version: 1.2 Revision Date: 01/30/2015 Print Date: 04/22/2015

Biodegradability (Product) : Result: No data available

Further information on ecology

Ecotoxicology Assessment
Results of PBT assessment (Product)
This substance is not considered to be persistent, bioaccumulating and toxic (PBT).
Additional ecological : There is no data available for this product.
information (Product)

SECTION 13. DISPOSAL CONSIDERATIONS

Disposal methods
Waste from residues : In accordance with local and national regulations.

Contaminated packaging : Do not burn, or use a cutting torch on, the empty drum.

SECTION 14. TRANSPORT INFORMATION

ADR
Not dangerous goods

RID
Not dangerous goods

MERCOSUR
Not dangerous goods

DOT
Not dangerous goods

IATA
Not dangerous goods

IMDG
Not dangerous goods

SECTION 15. REGULATORY INFORMATION

TSCA list : Not relevant

Not relevant

SAP 6.0 SDS 2012-2 NA GHS 8 / 10 SDS Number: 400000001740

 SAFETY DATA SHEET

ROYCO 555 DOD-PRF-85734

Version: 1.2 Revision Date: 01/30/2015 Print Date: 04/22/2015

EPCRA - Emergency Planning and Community Right-to-Know Act

CERCLA Reportable Quantity

Components CAS-No. Component RQ Calculated product RQ

(lbs) (lbs)
amitrole 61-82-5 10 *
*: Calculated RQ exceeds reasonably attainable upper limit.
SARA304 Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.

SARA 311/312 Hazards : Chronic Health Hazard

SARA 302 : No chemicals in this material are subject to the reporting

requirements of SARA Title III, Section 302.

SARA 313 : This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.

US State Regulations
California Prop 65 WARNING! This product contains a chemical known to the
State of California to cause cancer.
amitrole 61-82-5
The components of this product are reported in the following inventories:
US.TSCA On TSCA Inventory
DSL All components of this product are on the Canadian DSL.
AICS Not in compliance with the inventory
NZIoC Not in compliance with the inventory
ENCS Not in compliance with the inventory
KECI Not in compliance with the inventory
PICCS Not in compliance with the inventory
IECSC Not in compliance with the inventory

SECTION 16. OTHER INFORMATION

Further information

Other Emergency Phone Number

Latin America: Brazil +55 113 711 9144

All other countries +44 (0) 1235 239 670
Mexico: +52 555 004 8763

The information provided in this Safety Data Sheet is correct to the best of our knowledge,
information and belief at the date of its publication. The information given is designed only as
a guidance for safe handling, use, processing, storage, transportation, disposal and release
SAP 6.0 SDS 2012-2 NA GHS 9 / 10 SDS Number: 400000001740
 SAFETY DATA SHEET

ROYCO 555 DOD-PRF-85734

Version: 1.2 Revision Date: 01/30/2015 Print Date: 04/22/2015

and is not to be considered a warranty or quality specification. The information relates only to
the specific material designated and may not be valid for such material used in combination
with any other materials or in any process, unless specified in the text.

SAP 6.0 SDS 2012-2 NA GHS 10 / 10 SDS Number: 400000001740