MSDS Number* NABAKEM NBM-8002 PAGE

Material Safety Data Sheet MEGA CHECK PENETRANT ( 1 /6 )

SECTION 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION

Identity (Trade Name As Used On Label); MEGA CHECK PENETRANT

Chemical Family; Blended Compound

Manufacturer Name /Address:

NAMBANG CNA CO., LTD. /392-3 Chupal-ri, Paengsung-Eup, Pyongtaek-si, Kyonggi-do,

KOREA 451-805
TEL: 8231 651 5911-8 FAX: 8231 691 6441 /8231 6586441

Date Prepared; Mar. 07. 2007

SECTION 2. HAZARD IDENTIFICATION

Hazard Class

Hazard Class Hazard category

Flammable aerosols 1

Serious eye irritation 2

Skin sensitizer 1

GHS label elements, including precautionary statements

Category Indication

Symbol
<®><!>
Signal word Danger
- Extremely flammable aerosol
Hazard statement - Causes skin irritation
- May cause allergic skin reaction
- Pressurized container: Do not pierce or burn, even after use.
- Do not spray on an open flame or any white-hot material.
- Keep away from ignition sources such as heat/sparks/open
flames-No smoking.
- Wear eye/face protection as specified by the manufacturer/
Precautionary supplier or the competent authority.
Prevention
statements - Wear protective gloves as specified by the manufacturer/supplier
or the competent authority.
- Avoid breathing dust/fume/gas/mist/vapours/spray.
- Contaminated work clothing should not be allowed out of the
workplace.

- IF IN EYES: Rinse cautiously with water for several minutes.

Response
n.
,~ ''';;.,'' ,<;>
,.
, .... .. ,....
, ''"' -, '"'V. vv .. ," 'u<;> ..
",,,,~ .
- If eye irritation persists, get medical advice/attention.
 MSDS Number* NABAKEM NBM-BOO2 PAGE
MEGA CHECK PENETRANT (2 / 6 )

- Wash hands after handling

- IF ON SKIN: Wash with plenty of soap and water.
- If skin irritation or rash occurs, seek medical advice/attention.
- Wash contaminated clothing before reuse.

Storage
- Protect from sunlight and do not expose to temperatures
exceeding 50 "C
- Dispose of contents/container to ...... (in accordance with local/
Disposal
regional/national/international regulation).

Other hazards which do not result in classification : No inform ation found

SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS

INGREDIENTS CAS NUMBER %* Hazardous

Aromatic solvent 64742-94-5 40-50 -

Diacetone alcohol 123-42-2 5-15 -
Castor oil 8001-79-4 1-10 -
Red oil 1320-06-5 <3 -

Liquefied petroleum gas 68476-85-7 25-35 -

SECTION 4. FIRST AID PROCEDURES

Inhalation; Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give

oxygen. Call a physician.

Eye; Immediately flush eyes with plenty of water for at least 15 minutes, lifting lower and upper eyelids

occasionally. Get medical attention immediately.

Skin; Immediately flush skin with plenty of soap and water for at least 15 minutes while removing
contaminated clothing and shoes. Get medical attention. Wash clothing before reuse. Thoroughly

clean shoes before reuse.

Ingestion; Aspiration hazard. If swallowed, DO NOT INDUCE VOMITING. Give large quantities of water.
Never give anything by mouth to an unconscious person. Get medical attention immediately. If

vomiting occurs, keep head below hips to prevent aspiration into lungs.

SECTION 5. FIRE-FIGHTING MEASURES

Suitable extinguishing media; Dry chemical, foam or carbon dioxide. Water may be ineffective
 MSDS Number* NABAKEM NBM-8002 PAGE

MEGA CHECK PENETRANT ( 3 16 )

Specific hazards arising from the chemical; No information found

Special protective equipment and precautions for fire fighters; In the event of a fire, wear full protective
clothing and NIOSH-approved self-contained breathing apparatus with full facepiece

operated in the pressure demand or other positive pressure mode. Water spray may be
used to keep fire exposed containers cool. Vapors can flow along surfaces to distant
ignition source and flash back. Vapor explosion hazard exists indoors, outdoors, or in

sewers.

SECTION 6. ACCIDENTAL RELEASE MEASURES

Remove all sources of ignition. Ventilate area of leak or spill. Wear appropriate personal protective
equipment as specified in Section 8. Isolate hazard area. Keep unnecessary and unprotected personnel
from entering. Contain and recover liquid when possible. Collect liquid in an appropriate container or

absorb with an inert material (e. g., vermiculite, dry sand, earth), and place in a chemical waste

container. Do not use combustible materials, such as saw dust. Do not flush to sewer!

SECTION 7. HANDLING AND STORAGE

Protect against physical damage. Store in a cool, dry well-ventilated location, away from direct sunlight

and any area where the fire hazard may be acute. Store in tightly closed containers (preferably under

nitrogen atmosphere). Outside or detached storage is preferred. Inside storage should be in a standard
flammable liquids storage room or cabinet. Separate from oxidizing materials. Containers should be
bonded and grounded for transfers to avoid static sparks. Storage and use areas should be No Smoking
areas. Use non-sparking type tools and equipment. Containers of this material may be hazardous when

empty since they retain product residues (vapors, liquid); observe all warnings and precautions listed for

the product.

SECTION 8. EXPOSURE CONTROLS / PERSONAL PROTECTION

Airborne Exposure Limits;

Aromatic solvent:
200 mglm' ACGIH TWA (skin)
100 mglm' NIOSH
Diacetone alcohol :
TWA : 50 ppm, 240 mgl m'
 MSDS Number* NABAKEM NBM-8002 PAGE

MEGA CHECK PENETRANT (4/6)

STEL: -
50 ppm (240 mg/m') OSHA TWA

50 ppm ACGIH TWA

Liquefied petroleum gas :
1000 ppm (1800 mg/m') OSHA TWA

1000 ppm ACGIH TWA

Ventilation System; A system of local and/or general exhaust is recommended to keep employee

exposures below the Airborne Exposure Limits. Local exhaust ventilation is generally preferred
because it can control the emissions of the contaminant at its source, preventing dispersion of it
into the general work area. Please refer to the ACGIH document, Industrial Ventilation, A Manual

of Recommended Practices, most recent edition, for details.

Respiratory Protection; A NIOSH/MSHA chemical cartridge respirator should be worn if PEL or TLV is

exceeded.
Eye Protection; Use face shield, goggled or safety glasses.

Protective Gloves; Use solvent resistant gloves for brushing and spraying.

Other Protective Clothing and Equipment; Lab coat, eye wash, and safety shower.
Hygienic Work Practices; Wash hands with soap and water after use and/or before breaks, lunch and at

the end of work periods. Remove contaminates clothing and launder before reuse.

SECTION 9. PHYSICAL / CHEMICAL CHARACTERISTICS

Appearance; Red oil liquid

Odor; Solvent odor

Il Odour threshold; No information found

Ph; No information found

Melting point/freezing point; No information found

Initial boiling point and boiling range; No information found
Flash point; -73·C(Liquefied petroleum gas)

Evaporation rate; No information found

Flammability (solid, gas); No information found

Upper/lower flammability or explosive limits; 1.9/9.5% (Liquid petroleum gas)

Vapour pressure; No information found

Vapour density; No information found
Specific Gravity (H20 = 1) : 0.90 ± 0.05
Relative density; No information found
 MSDS Number* NABAKEM NBM-8002 PAGE
MEGA CHECK PENETRANT ( 5/6 )

Solubility(ies); Insoluble
Partition coefficient: n-octanol/water: No information found
Auto-ignition temperature; No information found

Decomposition temperature; No information found

Viscosity: No information found

SECTION 10. STABILITY AND REACTIVITY

STABILITY: Stable under ordinary conditions of use and storage

Hazardous Polymerization: Will not occur.

Conditions to Avoid: Heat, flames, ignition sources and incompatibles
Incompatability (Materials to Avoid) : Strong oxidizers.
Hazardous Decomposition Products: carbon oxide

SECTION 11. TOXICOLOGICAL INFORMATION

Ingestion: Oral rat LD50 : 2520mg/kg (Diacetone alcohol)

Oral rat LD50 : 2520mg/kg (Liquefied petroleum gas)

Skin: Skin rabbit LD50 : >2ml/kg (Aromatic solvent)

Skin rabbit LD50 : 13500mg/kg (Diacetone alcohol)

Inhalation: Inhalation rat LD50 : >590mg/m3/4hr (Aromatic solvent)

Other data: No information found

SECTION 12. ECOLOGICAL INFORMATION

Toxicity; No information found

Persistence and degradability; No information found

Bioaccumulative potential; No information found

Mobility in soil; No information found
Other adverse effects; No information found

SECTION 13. DISPOSAL CONSIDERATION

Whatever cannot be saved for recovery or recycling should be managed in an appropriate and approved
waste disposal facility. Processing, use or contamination of this product may change the waste
, .

MSDS Number· NABAKEM NBM-8002 PAGE

MEGA CHECK PENETRANT (6 /6 )

management options. State and local disposal regulations may differ from federal disposal regulations.
Dispose of container and unused contents in accordance with federal, state and local requirements.

SECTION 14. TRANSPORT INFORMATION

Proper Shipping Name Aerosol Class No 2

UN-NUMBER: UN 1950

SECTION 15. REGULATORY INFORMATION

Follow all regulation in your country

SECTION 16. OTHER INFORMATION

This information has been faithfully prepared on the basis of various knowledge and information and is

not to guarantee the quality of this product. Also, this information can be changed without prior notice in
accordance with introduction of new knowledge and test results, etc. For inquiries, please contact us or

the place of product purchase.