BMC Hiace

FOREWORD
This wiring diagram manual has been prepared to provide

information on the electrical system of the HIACE.
This manual applies to the models listed below. It covers all

information in the previously issued Pub. No. EM04Z1E, and
includes all production changes effective Apr. 2009 or later.
Applicable models: TRH201, 203, 213, 221, 223 Series

KDH200, 201, 202, 203, 212, 220,
221, 222, 223 Series
LH200, 202, 212, 222 Series
Refer to the following manuals for additional service

specifications and repair procedures for these models:
Manual Name Pub. No.

HIACE Repair Manual RM04Z2E
All information in this manual is based on the latest product

information at the time of publication. However, specifications
and procedures are subject to change without notice.
NOTICE
Always follow the directions given in the above repair manuals when handling
supplemental restraint system components (such as removal, installation,
inspection, etc.) in order to prevent accidents and supplemental restraint
system malfunction.
©2009
All rights reserved. This book may not be
reproduced or copied, in whole or in part, without
the written permission of Toyota Motor
Corporation.
HIACE
ELECTRICAL WIRING DIAGRAM
Section Code Page
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A . . . . 2
HOW TO USE THIS MANUAL . . . . . . . . . . . . . . . . . . B . . . . 3
TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . C . . . . 12
ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . D . . . . 17
GLOSSARY OF TERMS AND SYMBOLS . . . . . . E . . . . 18
RELAY LOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . F . . . . 20
ELECTRICAL WIRING ROUTING . . . . . . . . . . . . . . G . . . . 44
SYSTEM CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . H . . . . 78
GROUND POINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . I . . . . 290
POWER SOURCE (Current Flow Chart) . . . . . . . J . . . . 302
CONNECTOR LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . K . . . . 310
PART NUMBER OF CONNECTORS . . . . . . . . . . . L . . . . 334
OVERALL ELECTRICAL WIRING DIAGRAM . . M . . . . 338
HIACE (EM04Z2E)
A INTRODUCTION
This manual consists of the following 13 sections:
No. Section Description
INDEX Index of the contents of this manual.

A
INTRODUCTION Brief explanation of each section.
HOW TO USE THIS

B Instructions on how to use this manual.
MANUAL
TROUBLE–
C Describes the basic inspection procedures for electrical circuits.
SHOOTING
D ABBREVIATIONS Defines the abbreviations used in this manual.
GLOSSARY OF
E TERMS AND Defines the symbols and functions of major parts.
SYMBOLS
Shows position of the Electronic Control Unit, Relays, Relay Block, etc.
F RELAY LOCATIONS
This section is closely related to the system circuit.
ELECTRICAL Describes position of Parts Connectors, Splice points, Ground points, etc.
G
WIRING ROUTING This section is closely related to the system circuit.
INDEX Index of the system circuits.
Electrical circuits of each system are shown from the power supply through ground
H points. Wiring connections and their positions are shown and classified by code
according to the connection method. (Refer to the section, ”How to use this manual”).
SYSTEM CIRCUITS
The ”System Outline” and ”Service Hints” useful for troubleshooting are also contained
in this section.
(Only wiring information for complete circuits is included.)
I GROUND POINT Shows ground positions of all parts described in this manual.
POWER SOURCE
J Describes power distribution from the power supply to various electrical loads.
(Current Flow Chart)
Describes the form of the connectors for the parts appeared in this book.
K CONNECTOR LIST
This section is closely related to the system circuit.
PART NUMBER OF
L Indicates the part number of the connectors used in this manual.
CONNECTORS
OVERALL
Provides circuit diagrams showing the circuit connections.
M ELECTRICAL
(Only wiring information for complete circuits is included.)
WIRING DIAGRAM
HIACE (EM04Z2E)
HOW TO USE THIS MANUAL B
This manual provides information on the electrical circuits installed on vehicles by

dividing them into a circuit for each system.
The actual wiring of each system circuit is shown from the point where the power
source is received from the battery as far as each ground point. (All circuit
diagrams are shown with the switches in the OFF position.)
When troubleshooting any problem, first understand the operation of the circuit
where the problem was detected (see System Circuit section), the power source
supplying power to that circuit (see Power Source section), and the ground points
(see Ground Point section).
When the circuit operation is understood, begin troubleshooting of the problem

circuit to isolate the cause. Use Relay Location and Electrical Wiring Routing
sections to find each part, junction block and wiring harness connectors, wiring
harness and wiring harness connectors and ground points of each system circuit.
Internal wiring for each junction block is also provided for better understanding of
connection within a junction block.
Wiring related to each system is indicated in each system circuit by arrows
(from__, to__). When overall connections are required, see the Overall Electrical
Wiring Diagram at the end of this manual.
Example:
*The information in this manual is Front right door When inspecting or repairing,
refer to the Repair Manual.
about the wire harnesses.
Information about component and
assembly parts is for reference,
but in some cases this reference
information might not be included or
might differ from the actual vehicle.
When inspecting or repairing a vehicle,
refer to the relevant Repair Manual.
Wire harness
Component parts
Assembly parts
HIACE (EM04Z2E)
B HOW TO USE THIS MANUAL
* The system shown here is an EXAMPLE ONLY. It is different to the actual
circuit shown in the SYSTEM CIRCUITS SECTION.
[A]
Stop Light
[M]
(BAT) (IG)
15A 7.5A
STOP GAUGE
[B] 1 3 IB 4 IB
R–L
W–R
(S/D)
7 3C
L
[C] [G]
H6
Stop Lamp SW
14 CH1 15 3C
R–L
(W/G)
(S/D)
R
L
G–W
Combination Meter
4
Skid Control ECU
15 CH1 [E]
Lights
with Actuator
Rear
G–W
[D]
H7
13
(S/D)
L
G–W
[F] [O]
Y–G
H4
7 8 Light Failure Sensor 4
2 1 11
[I]
G–R
1
G–R
HJ1 [N]
[H]
W–B
G–B
Rear Combination Lamp (RH)
Rear Combination Lamp (LH)

G–R
(Shielded)
G–R
4 3
2
H17
[J]
Stop
Stop
Center Stop
Lamp
1
H9
J7
3 6
W–B
W–B
W–B
1
W–B
HJ1
W–B
H1 [K] H2
50 [L]
HIACE (EM04Z2E)
B
[A] : System Title [I] : Indicates the wiring color.
[B] : Indicates a Relay Block. No shading is used and Wire colors are indicated by an alphabetical code.
only the Relay Block No. is shown to distinguish it B = Black W = White BR = Brown
from the J/B
L = Blue V = Violet SB = Sky Blue
Example: Indicates Relay Block No.1
R = Red G = Green LG = Light Green
[C] : ( ) is used to indicate different wiring and P = Pink Y = Yellow GR = Gray
connector, etc. when the vehicle model, engine
type, or specification is different. O = Orange BE = Beige
The first letter indicates the basic wire color and the
[D] : Indicates related system. second letter indicates the color of the stripe.
[E] : Indicates the code for the (male and female)
connectors which are used to join two wire Example: L–Y
harnesses. The connector code consists of two
alphabetical and one numerical characters.
L Y
(Blue) (Yellow)
[J] : Indicates the pin number of the connector.

The numbering system is different for female and
Female Male ( ) male connectors.
The first character of the connector code indicates Example: Numbered in order Numbered in order
the alphabetical code allocated to the wire harness from upper left to from upper right to
which has the female connector, and the second lower right lower left
shows that of the wire harness which has the male
connector.
The third character indicates a serial number used
to distinguish between the wire harness
combinations in cases when more than one of the Female Male
same combination of wire harnesses exist
(e.g. CH1 and CH2). [K] : Indicates the ground point. The code consists of the
two characters: A letter and number.
Symbol ( ) indicates the male terminal connector. The first character of the code indicates the
Numbers outside connector codes indicate the pin alphabetical code allocated to the wire harness.
numbers of both male and female connectors. The second character indicates a serial number
used to distinguish between the ground points in
[F] : Represents a part (all parts are shown in sky blue). cases when more than one ground point exist on the
The code is the same as the code used in parts same wire harness.
position.
[L] : Page No.
[G] : Junction Block (The number in the circle is the J/B
No. and the connector code is shown beside it). [M] : Indicates the ignition key position(s) when the
Junction Blocks are shaded to clearly separate power is supplied to the fuse(s).
them from other parts. [N] : Indicates a wiring Splice Point.
Example:
Example:
3C indicates that
it is inside
Junction Block
No.3
[O] : Wire Harness Code
Each wire harness is represented by a code.
Wire harness codes are used in the parts codes,
[H] : Indicates a shielded cable. connector joining wire harness and wire harness
codes, and ground point codes. For example,
H7 (combination meter), CH1 (male, connector
joining wire harness and wire harness), and H2
(ground point) indicate that they are the parts
belonging to the same wire harness "H".
HIACE (EM04Z2E)
[P] : Parts Location
Code See Page Code See Page Code See Page
H4 36 H7 36 H17 38
H6 36 H9 38 J7 38
[Q] : Relay Blocks
Code See Page Relay Blocks (Relay Block Location)

1 18 R/B No.1 (Instrument Panel Brace LH)
[R] : Junction Block and Wire Harness Connector
Code See Page Junction Block and Wire Harness (Connector Location)
3C 22 Instrument Panel Wire and J/B No.3 (Instrument Panel Brace LH)
IB 20 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
[S] : Connector Joining Wire Harness and Wire Harness

Code See Page Joining Wire Harness and Wire Harness (Connector Location)
CH1 42 Engine Room Main Wire and Instrument Panel Wire (Left Kick Panel)
HJ1 50 Instrument Panel Wire and Floor Wire (Right Kick Panel)
[T] : Ground Points
Code See Page Ground Points Location

H1 50 Under the Left Center Pillar
H2 50 Back Panel Center
HIACE (EM04Z2E)
B
[P] : Indicates reference pages showing the parts locations in the system circuit on the vehicle.
Example : Code ”H4” (Light Failure Sensor) is on page 36 of the manual.
* The first character of the code indicates the alphabetical code allocated to the wire harness, and the
second character indicates the serial number of the parts connected to the wire harness.
Example : H 4
Serial number for the connected parts
Code for the wire harness
[Q] : Indicates the reference page showing the position on the vehicle of Relay Block Connectors in the system circuit.
Example : Connector ”1” is described on page 18 of this manual and is installed on the left side of the instrument
panel.
[R] : Indicates the reference page showing the position on the vehicle of J/B and Wire Harness in the system circuit.
Example : Connector ”3C” connects the Instrument Panel Wire and J/B No.3. It is described on page 22 of this
manual, and is installed on the instrument panel left side.
[S] : Indicates the reference page describing the wiring harness and wiring harness connector (the female wiring
harness is shown first, followed by the male wiring harness).
Example : Connector ”CH1” connects the Engine Room Main Wire (female) and Instrument Panel Wire (male).
It is described on page 42 of this manual, and is installed on the left side kick panel.
[T] : Indicates the reference page showing the position of the ground points on the vehicle.
Example : Ground point ”H2” is described on page 50 of this manual and is installed on the back panel center.
HIACE (EM04Z2E)
The ground points circuit diagram shows the connections from all major parts to the respective ground points. When
troubleshooting a faulty ground point, checking the system circuits which use a common ground may help you identify
the problem ground quickly. The relationship between ground points ( A1 , A2 and D4 shown below) can also be
checked this way.
I GROUND POINT
D43
Junction
H23 Connector
12 9
DLC3 BR BR BR 10 6 (Shielded)
(SG) HB4 DB1
D63
5 BR Throttle
(L)
(Shielded)
(Shielded)
Position SW
D60
A20 4 3 BR Injection
W–B 8 (E1) Pump Assembly
Headlamp Leveling
Motor (LH) (LH E)
L5 2 11 BR
W–B 3 W–B 7 (E1)
Power Window
Master SW (E) LA1
1 D2
BR Engine ECU
(E01)
Connector
A22
BR
W–B 4 Junction
Cooling Fan
Motor No.3 (E) BR
A25
(E02)
3
W–B
D4 (5L–E)
A8
Headlamp Leveling W–B
Motor (RH) (RH E)
A5 C2
W–B W–B
W–B
Pressure SW Fog Lamp

(–S) (E) (Front LH)
A23 5 C4
Turn Signal Lamp W–B W–B W–B W–B Fog Lamp
(Front LH) (E) CA1 (E) (Front RH)
A11 A10
W–B W–B
W–B
Windshield Brake Fluid Level

Wiper Motor (E) (E) Warning SW
I9 12 7 A1
Headlamp W–B W–B W–B W–B Turn Signal Lamp
Leveling SW (E) IH2 HA1 (E) (Front RH)
W–B
A6
Clearance Lamp W–B K5
(Front RH) (E) 3
W–B W–B Power Window
KA1 (E) Master SW
W–B
A21
Clearance Lamp W–B W–B
(Front LH) (E)
20 W – B (Shielded)
A1
19 W – B (Shielded)
W–B
(GND2) 18 W – B (Shielded)
A24
Option Connector
(Vacuum)
Connector
W–B
Junction
(GND1) 17 W – B (Shielded)
W–B
B36
21 16
W–B W–B
(GND) AB1
W–B
B19
Skid Control ECU
with Actuator 12 6
W–B W–B W–B
(GND) AB1 AB1
W–B
W–B
W–B
A2
* The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
HIACE (EM04Z2E)
B
The ”Current Flow Chart” section, describes which parts each power source (fuses, fusible links, and circuit breakers)
transmits current to. In the Power Source circuit diagram, the conditions when battery power is supplied to each system
are explained. Since all System Circuit diagrams start from the power source, the power source system must be fully
understood.
J POWER SOURCE (Current Flow Chart)

The chart below shows the route by which current flows from the battery to each electrical source
(Fusible Link, Circuit Breaker, Fues, etc.) and other parts
10A ECU–B
Short Pin 2 2
7.5A DOME
15A EFI
Battery 30A AM2 2 Fusible Link Block 6 10A HAZARD

2
20A RADIO NO.1
Starter S2
10A HORN
100A ALT 6 60A ABS 5
Engine Room R/B (See Page 20)

Fuse System Page
ABS 194
ABS and Traction Control 187
20A STOP Cruise Control 180
Electronically Controlled Transmission 166
Multiplex Communication System 210
Cigarette Lighter 214
Combination Meter 230
Headlight 112
10A DOME Interior Light 122
Key Reminder and Seat Belt Warning
Light Auto Turn Off System
Theft Deterrent and Door Lock Control
Power Source
1.25B
B 1 FL MAIN
W
BA1
Battery
50A MAIN 7.5A DOME
B W 7 W W 1 2 R
1 2
2 2 AH1 1 1
7.5A AM1
B W–R 6
1 2
2 2 AH1
W
W–R
15A HAZ–RADIO
1 2 W
2
8 4
AM1
AM2
H8
Ignition SW
ACC
ST1
ST2
IG1
IG2
2
20A DEFOG
B–Y 1 2 W–R
1 1
* The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
HIACE (EM04Z2E)
K CONNECTOR LIST
A1 [A] A2 A3 [C]
Black Gray
1 2 3 4 1 2 3 4 5 6 7
1 2 3 4
5 6 7 8
[B] [D]
B1 B2
Black Gray
1 2
3 4 5 6
1 2 3 4 5
6 7 8 9 10111213
K CONNECTOR LIST
BA1 Black
[E] BD2 Gray [F]
1 2 3 4 4 3 2 1
1 2 3 4 5 5 4 3 2 1 5 6 7 8 9 10 11 11 10 9 8 7 6 5
6 7 8 9 10 11 12 13 13 12 11 10 9 8 7 6
[A] : Indicates connector to be connected to a part. (The numeral indicates the pin No.)
[B] : Junction Connector

Indicates a connector which is connected to a short terminal.
Junction Connector
Junction connector in this manual include a short terminal which is

connected to a number of wire harnesses. Always perform
inspection with the short terminal installed.
Short Terminal
[C] : Parts Code

The first letter of the code is taken from the first letter of part, and the numbers indicates its order in parts which
start with the same letter.
[D] : Connector Color

Connectors not indicated are milky white in color.
[E] : Indicates the connector shapes which are used to join wire harnesses.
On Left : Female connector shapes
On Right : Male connector shapes
Numbers indicate pin numbers.
[F] : Indicates connector colors. (Connectors with not indicated colors are white)
10
HIACE (EM04Z2E)
B
L PART NUMBER OF CONNECTORS

Code Part Name Part Number Code Part Name Part Number
A1 Turn Signal Lamp (Front RH) 90980–11019 B22 Door Courtesy SW (Front LH) 90980–12470
A2 Inlet Air Temp. Sensor 90980–11163 B23 Front Seat Outer Belt (LH) 90980–12253
A3 Air Flow Meter 90980–12292 B24 Blower SW (Rear Heater) 90980–10463
A4 A/C Pressure Sensor 90980–10845 B25 Front Seat Outer Belt (RH) 90980–12253
A5 Pressure SW 90980–10943 B26 Door Courtesy SW (Front RH) 90980–12470
A6 Clearance Lamp (Front RH) 90980–11156 B27 Cooling Fan ECU No.1
90980–10841
[A]
A7 [B](RH)
Headlamp [C]
90980–11314 B28 Cooling Fan ECU No.2
A8 Headlamp Leveling Motor (RH) 90980–11016 B29 Water Temp. Sensor (Radiator) 90980–10735
A9 Brake Vacuum Warning SW 90980–11252 B30 Fuel Filter Warning SW 90980–11003
A10 Brake Fluid Level Warning SW 90980–11207 B32 Door Control Relay (LH) 90980–10789
A11 Windshield Washer Motor 90980–11599 B33 Step Lamp (LH) 90980–10121
A12 Airbag Sensor (Front RH) 90980–11856 B34 Junction Connector
A13 Airbag Squib B35 Junction Connector 90980–11398

90980–12490
[A] : Part Code
[B] : Part Name
[C] : Part Number

Toyota Part Number are indicated.
Not all of the above part numbers of the connector are established for the supply.
11
HIACE (EM04Z2E)
C TROUBLESHOOTING
To Ignition SW VOLTAGE CHECK
IG Terminal
(a) Establish conditions in which voltage is present at the check
point.
Example:
Fuse [A] – Ignition SW on
[B] – Ignition SW and SW 1 on
[A] [C] – Ignition SW, SW 1 and Relay on (SW 2 off)
(b) Using a voltmeter, connect the negative lead to a good ground
SW 1 Voltmeter point or negative battery terminal, and the positive lead to the
connector or component terminal.
[B] This check can be done with a test light instead of a voltmeter.
Relay
[C]
SW 2 Solenoid
CONTINUITY AND RESISTANCE CHECK

(a) Disconnect the battery terminal or wire so there is no voltage
between the check points.
Ohmmeter
(b) Contact the two leads of an ohmmeter to each of the check
points.
SW
If the circuit has diodes, reverse the two leads and check
again.
When contacting the negative lead to the diode positive side
Ohmmeter and the positive lead to the negative side, there should be
continuity.
When contacting the two leads in reverse, there should be no
continuity.
Diode
Digital Type Analog Type (c) Use a volt/ohmmeter with high impedance (10 k /V
minimum) for troubleshooting of the electrical circuit.
12
HIACE (EM04Z2E)
C
To Ignition SW FINDING A SHORT CIRCUIT
IG Terminal
(a) Remove the blown fuse and disconnect all loads of the fuse.
(b) Connect a test light in place of the fuse.
(c) Establish conditions in which the test light comes on.
Test Light Fuse Case Example:
[A] – Ignition SW on
Short [A]
[B] – Ignition SW and SW 1 on
[C] – Ignition SW, SW 1 and Relay on (Connect the
Relay) and SW 2 off (or Disconnect SW 2)
SW 1 (d) Disconnect and reconnect the connectors while watching the
test light.
Short [B] The short lies between the connector where the test light
stays lit and the connector where the light goes out.
Disconnect
Disconnect (e) Find the exact location of the short by lightly shaking the
problem wire along the body.
Light Relay
CAUTION:
(a) Do not open the cover or the case of the ECU unless
Short [C] absolutely necessary. (If the IC terminals are touched,
the IC may be destroyed by static electricity.)
(b) When replacing the internal mechanism (ECU part) of
Disconnect
the digital meter, be careful that no part of your body or
clothing comes in contact with the terminals of leads
SW 2 Solenoid from the IC, etc. of the replacement part (spare part).
DISCONNECTION OF MALE AND FEMALE

CONNECTORS
To pull apart the connectors, pull on the connector itself, not
the wire harness.
HINT : Check to see what kind of connector you are
disconnecting before pulling apart.
Pull Up Pull Up
Press Down Press Down
13
HIACE (EM04Z2E)
C TROUBLESHOOTING
Reference: HOW TO REPLACE TERMINAL
(with terminal retainer or secondary locking device)
10 1. PREPARE THE SPECIAL TOOL
3 1
HINT : To remove the terminal from the connector, please
construct and use the special tool or like object shown on
the left.
2. DISCONNECT CONNECTOR
0.2
1 (mm)
Example: Up 3. DISENGAGE THE SECONDARY LOCKING DEVICE OR

Tool
(Case 1)
TERMINAL RETAINER.
(a) Locking device must be disengaged before the terminal

locking clip can be released and the terminal removed from
the connector.
(b) Use a special tool or the terminal pick to unlock the secondary
locking device or terminal retainer.
NOTICE:
Terminal Retainer Do not remove the terminal retainer from connector body.
[A] For Non–Waterproof Type Connector

Terminal Retainer
HINT : The needle insertion position varies according to the

connector’s shape (number of terminals etc.), so
check the position before inserting it.
”Case 1”
[Retainer at Full Lock Position] Raise the terminal retainer up to the temporary lock
position.
Terminal
Stopper Retainer
[Retainer at Temporary Lock Position]
Example: Secondary ”Case 2”

(Case 2) Locking Device
Open the secondary locking device.
14
HIACE (EM04Z2E)
C
Tool
Tab
Tab
Example: [B] For Waterproof Type Connector

Terminal
(Case 1) Retainer Tool
HINT : Terminal retainer color is different
according to connector body.
Example:
Terminal Retainer : Connector Body
Black or White : Gray
Black or White : Dark Gray
Tool Access Hole Gray or White : Black
[Male] ( Mark) [Female]
”Case 1”
Type where terminal retainer is pulled
up to the temporary lock position (Pull
Type).
Insert the special tool into the terminal

retainer access hole ( Mark) and pull
the terminal retainer up to the
temporary lock position.
Retainer
at Full Lock Position HINT : The needle insertion position varies
according to the connector’s shape
(Number of terminals etc.), so check
the position before inserting it.
Retainer
at Temporary Lock Position
[Male] [Female]
Example: Terminal Retainer ”Case 2”

(Case 2) Type which cannot be pulled as far as
Power Lock insert the tool straight into
the access hole of terminal retainer as
shown.
Tool Tool
Press Down
[Male] Press Down [Female]
15
HIACE (EM04Z2E)
C TROUBLESHOOTING
Push the terminal retainer down to the temporary lock position.
Retainer at
Full Lock Position
Retainer at
Temporary Lock Position
[Male] [Female]
Locking Lug (c) Release the locking lug from terminal and pull the terminal out
from rear.
Tool
4. INSTALL TERMINAL TO CONNECTOR
(a) Insert the terminal.

HINT:
1. Make sure the terminal is positioned correctly.
2. Insert the terminal until the locking lug locks firmly.
3. Insert the terminal with terminal retainer in the temporary lock
position.
(b) Push the secondary locking device or terminal retainer in to

the full lock position.
5. CONNECT CONNECTOR
16
HIACE (EM04Z2E)
ABBREVIATIONS D
ABBREVIATIONS
The following abbreviations are used in this manual.
A/C = Air Conditioner

A/T = Automatic Transmission
ABS = Anti-Lock Brake System
CAN = Controller Area Network
DLC3 = Data Link Connector 3
ECT = Electronic Control Transmission
ECU = Electronic Control Unit
EDU = Electronic Driving Unit
EGR = Exhaust Gas Recirculation
FL = Fusible Link
G.C.C. = Gulf Cooperation Council
IC = Integrated Circuit
INT = Intermittent
J/B = Junction Block
LCD = Liquid Crystal Display
LH = Left-Hand
LHD = Left-Hand Drive
M/T = Manual Transmission
PTC = Positive Temperature Coefficient
R/B = Relay Block
RH = Right-Hand
RHD = Right-Hand Drive
SPEC. = Specification
SRS = Supplemental Restraint System
SW = Switch
TEMP. = Temperature
TVSS = TOYOTA Vehicle Security System
VRV = Vacuum Regulating Valve
VSV = Vacuum Switching Valve
w/ = With
w/o = Without
* The titles given inside the components are the names of the terminals (terminal codes) and are not treated as being
abbreviations.
17
HIACE (EM04Z2E)
E GLOSSARY OF TERMS AND SYMBOLS
BATTERY GROUND
Stores chemical energy and The point at which wiring attaches to
converts it into electrical energy. the Body, thereby providing a return
Provides DC current for the auto’s path for an electrical circuit; without a
various electrical circuits. ground, current cannot flow.
CAPACITOR (Condenser) HEADLIGHTS

A small holding unit for temporary Current flow causes a headlight
1. SINGLE
storage of electrical voltage. FILAMENT filament to heat up and emit light. A
headlight may have either a single
(1) filament or a double (2) filament
CIGARETTE LIGHTER
An electric resistance heating 2. DOUBLE
FILAMENT
element.
CIRCUIT BREAKER HORN

Basically a reusable fuse, a circuit An electric device which sounds a
breaker will heat and open if too loud audible signal.
much current flows through it.
Some units automatically reset when
cool, others must be manually reset.
DIODE IGNITION COIL
A semiconductor which allows Converts low–voltage DC current
current flow in only one direction. into high–voltage ignition current for
firing the spark plugs.
DIODE, ZENER LIGHT

A diode which allows current flow in one Current flow through a filament
direction but blocks reverse flow only up causes the filament to heat up and
to a specific voltage. Above that potential,
emit light.
it passes the excess voltage. This acts as
a simple voltage regulator.
PHOTODIODE LED (LIGHT EMITTING DIODE)

The photodiode is a semiconductor Upon current flow, these diodes emit
which controls the current flow light without producing the heat of a
according to the amount of light. comparable light.
DISTRIBUTOR, IIA METER, ANALOG

Channels high–voltage current from Current flow activates a magnetic
the ignition coil to the individual coil which causes a needle to move,
spark plugs. thereby providing a relative display
against a background calibration.
FUSE METER, DIGITAL

A thin metal strip which burns through Current flow activates one or many
when too much current flows through it, FUEL
LED’s, LCD’s, or fluorescent
thereby stopping current flow and displays, which provide a relative or
protecting a circuit from damage. digital display.
FUSIBLE LINK
(for Medium Current Fuse) A heavy–gauge wire placed in high
MOTOR
amperage circuits which burns through on
overloads, thereby protecting the circuit.
A power unit which converts
The numbers indicate the crosssection M electrical energy into mechanical
surface area of the wires. energy, especially rotary motion.
(for High Current Fuse or
Fusible Link)
18
HIACE (EM04Z2E)
E
RELAY SPEAKER
Basically, an electrically operated An electromechanical device which
1. NORMALLYswitch which may be normally creates sound waves from current
CLOSED closed (1) or open (2). flow.
Current flow through a small coil
creates a magnetic field which either
opens or closes an attached switch.
2. NORMALLY SWITCH, MANUAL
OPEN Opens and closes
circuits, thereby
1. NORMALLY
OPEN stopping (1) or
allowing (2) current
flow.
RELAY, DOUBLE THROW
A relay which passes current 2. NORMALLY
through one set of contacts or the CLOSED
other.
RESISTOR SWITCH, DOUBLE THROW

An electrical component with a fixed A switch which continuously passes
resistance, placed in a circuit to current through one set of contacts
reduce voltage to a specific value. or the other.
RESISTOR, TAPPED SWITCH, IGNITION

A resistor which supplies two or A key operated switch with several
more different non adjustable positions which allows various
resistance values. circuits, particularly the primary
ignition circuit, to become
operational.
RESISTOR, VARIABLE or RHEOSTAT
A controllable resistor with a variable
rate of resistance.
Also called a potentiometer or
rheostat.
SENSOR (Thermistor) SWITCH, WIPER PARK

A resistor which varies its resistance Automatically returns wipers to the
with temperature. stop position when the wiper switch
is turned off.
SENSOR, SPEED TRANSISTOR

Uses magnetic impulses to open A solidstate device typically used as
and close a switch to create a signal an electronic relay; stops or passes
for activation of other components. current depending on the voltage
(Reed Switch Type)
applied at ”base”.
SHORT PIN
WIRES
Used to provide an unbroken
Wires are always drawn as
connection within a junction block. (1) NOT straight lines on wiring
CONNECTED diagrams.
Crossed wires (1) without a
black dot at the junction are
SOLENOID not joined;
An electromagnetic coil which forms crossed wires (2) with a
a magnetic field when current flows, (2) SPLICED black dot or octagonal ( )
to move a plunger, etc. mark at the junction are
spliced (joined)
connections.
19
HIACE (EM04Z2E)
F RELAY LOCATIONS
[Engine Compartment]
* 1:1KD-FTV, 2KD-FTV, 5L-E Engine Room R/B No.1 (*2)

* 2:2TR-FE Engine Room J/B No.1 (*2)
* 3:1KD-FTV, 2KD-FTV
Engine Room
R/B No.2
Air Injection
Control Driver (*2)
Injection Driver
(EDU) (*3)
Skid Control
ECU with Actuator
Engine ECU
Engine Room R/B No.1 (*1) Cooling Fan Cooling Fan

Engine Room J/B No.1 (*1) ECU No.1 ECU No.2
[Body]
Door Control
Relay (RH)
Door Opening
Relay
Door Control
Receiver
Door Control
Relay (LH)
Door Control Relay

(Power Slide Door)
20
HIACE (EM04Z2E)
F
[Instrument Panel]
(LHD)
Transponder Key ECU A/C Amplifier
Center J/B
Clearance Warning
Integration Relay ECU
Fuse Box
Instrument
Panel J/B
Junction Transmission
Connector Control ECU
(CAN)
Transponder
Key Amplifier Shift Lock Airbag Sensor Instrument
Control ECU Assembly Center Panel R/B
(RHD)
Transponder A/C Amplifier Clealance Warning ECU
Key ECU
Instrument
Panel J/B
Center J/B
Integration
Relay
Junction
Connector
(CAN)
Transponder
Key Amplifier
Fuse Box Transmission

Control ECU
Instrument Airbag Sensor Shift Lock Turbo Motor

Panel R/B Assembly Center Control ECU Driver
21
HIACE (EM04Z2E)
F RELAY LOCATIONS
1 : Engine Room R/B No.1
Engine Compartment Front (See Page 20)
: Engine Room J/B No.1
[2TR-FE]
* 1:120A MAIN4 (for High Current)

* 2:40A HTR (for High Current)
* 3:30A RR CLR (for High Current)
* 4:140A ALT (for High Current)
* 5:50A A/PUMP (for High Current)
* 7:50A FAN2 (for High Current)
1 15A 2
A/F
*4
1 15A 2
*5 *1 HAZ-HORN
Unit B
Unit A *6
1 20A 2
*7 *2 EFI
*8 *3
RR CLR Relay
3
1 4 2
3
FAN1 Relay
FAN2 Relay
3
1 2 1 2
5 5
22
HIACE (EM04Z2E)
F
[1KD-FTV, 2KD-FTV, 5L-E]
* 1:50A PTC1 (for High Current)

* 3:40A HTR (for High Current)
* 4:30A RR CLR (for High Current)
* 5:50A PTC2 (for High Current)
* 6:140A ALT (for High Current)
* 7:80A GLOW (for High Current)
*6 *1
1 15A 2
*7 *2
HAZ-HORN
Unit B
*8
Unit A
1 25A 2
*9 *3 EFI
*10
*11 *4
*5
GLOW Relay
PTC2 Relay
PTC1 Relay
1 3 3
5 3 1 2 1 2
2 5 5
RR CLR Relay
FAN1 Relay
FAN2 Relay
1 3 3
5 4 3 1 2 1 2
2 5 5
23
HIACE (EM04Z2E)
F RELAY LOCATIONS
(from Engine Room (from Engine Room 1

Main Wire) Main Wire) (from Engine Room
Unit A 1B 1C
Main Wire)
Wire Coler : R
1 2 1 2
3 4 3 4 1H
3 4 3 4
Back View 1 2 1 2
1
(from Engine Room
Main Wire)
Wire Coler : B-G
Side View 1G
1F
1
(from Engine Room
Main Wire)
Wire Coler : W
Top View
Side View
1A 1D 1E
1 1 1
(from Engine Room (from Engine Room (from Engine Room
Main Wire) Main Wire) Main Wire)
Wire Coler : W Wire Coler : W Wire Coler : B-W
24
HIACE (EM04Z2E)
F
Unit B
Back View Top View
1
1 2
3
2
3 4
1I
4 5
5 6
7
6
7 8
8
(from Engine Room

Main Wire)
1
1 2
3
2
3 4
1J
4 5
5 6
7
6
7 8
8
(from Engine Room

Main Wire)
1K
1
1
(from Engine Room

Main Wire)
25
HIACE (EM04Z2E)
F RELAY LOCATIONS
[Engine Room R/B No.1 and Engine Room J/B No.1 Inner Circuit]
Unit A
1 1A
140A
ALT
50A PTC1
1 1D 1 1F
50A A/PUMP (*1)
80A GLOW (*2) 120A MAIN4
1 1E 1 1G
50A MAIN3
3 1B 1 1B
50A FAN2 40A HTR

4 1B 2 1B
30A FAN3
3 1C 1 1C
50A FAN1 30A RR CLR

4 1C 2 1C
50A PTC2
1 1H
* 1:2TR-FE
* 2:1KD-FTV, 2KD-FTV, 5L-E
26
HIACE (EM04Z2E)
F
Unit B 1 1I
A/F Relay (*1)
FAN3 Relay (*2)
1 2
1 1K 4 1I
15A A/F (*1)
3 1I
2 1I
5 1I
HORN Relay
1 2
8 1I
15A HAZ-HORN
7 1I
6 1I
1 1J
MAIN Relay
1 2
4 1J
20A EFI (*1)
25A EFI (*2)
3 1J
2 1J
5 1J
C/OPN Relay (*1)
EDU Relay (*2)
8 1J
(*2)
7 1J
6 1J
* 1:2TR-FE
27
HIACE (EM04Z2E)
F RELAY LOCATIONS
2 : Engine Room R/B No.2 Inside of Battery Room (See Page 20)
ECU-B
2 10A 1
ETCS TVSS
2 10A 1 2 15A 1
PSD DOME
2 25A 1 2 10A 1
ABS SOL RADIO ALT-S

2 25A 1 2 15A 1 1 7.5A 2
D.C.C
2 30A 1
40A HEAD 2 1 1 2 30A RR DOOR

(for High Current) (for High Current)
40A ABS MTR 2 1 1 2 30A AM2

(for High Current) (for High Current)
28
HIACE (EM04Z2E)
F
4 : Instrument Panel R/B Under the Glove Box (See Page 21)
HEAD LH
15A 2
1 HEAD RH
15A 2
ST
2 7.5A 1
A/C NO.3
2 7.5A 1
HEAD Relay 5 3
3
5 FR FOG Relay
1 2
1 1
ST Relay 5 3 5 3 MG CLT Relay
2 2
29
HIACE (EM04Z2E)
F RELAY LOCATIONS
: Instrument Panel J/B Left Side of Instrument Panel (See Page 21)
14 13 12 11 10 9 8 16 15 14 13 12 11 10 9
19 1
20 2 7 6 5 4 3 2 1 8 7 6 5 4 3 2 1
21 3
22 4
23 5 5B
24 6
25 7 (from Instrument Panel Wire) (from Instrument Panel Wire)
26 8 9 18
8 17
27 9 5D 5C 7 16
28 10 6 15
29 11 5 14
30 12 4 13
3 12
2 11
31 13
32 14 1 10
33 15
34 16
1 16 1 19 (from Instrument
35 17 2 17 2 20 7 6 5 4 3 2 1 Panel Wire)
3 21 8 7 6 5 4 3 2 1
3 18 14 13 12 11 10 9 8
36 18 4 22 16 15 14 13 12 11 10 9
4 19
5 20 5 23 5H
6 21 6 24
7 22 7 25
(from Cowl to Head 8 26
Lamp Wire) 18 9 1 17
8 23 9 27
28 17 8 2 18 17 1
9 24 10 3 19
10 25 11 29 16 7 18 2
15 6 4 20 19 3
16 1 11 26 12 30 5 21 20 4
17 2 5A 14 5 6 22 21 5
18 3 13 4 7 23 22 6
19 4 12 27 13 31 12 3 8 24 23 7
20 5 13 28 14 32 11 2 24 8
21 6 14 29 15 33 10 1 9 25 5E
22 7 15 30 16 34 10 26 25 9
17 35 11 27 26 10
23 8 18 36 12 28 27 11
24 9 4 28 12
25 10 3
26 11 2 13 29
1 3
1 14 30 29 13
4
1 15 31 30 14
27 12 5
16 32 31 15
28 13 2 6
2 32 16
29 14
30 15
2 (from Engine Room
3 2 1 Main Wire)
(from Roof Wire) 1 1
1 8 7 6 5 4
4
5J 3
3 1
4 5K 1 1
2
8 7 6 5 4 1
5
6 2 5 3 5 4 3 3 2 1
(from Instrument
Panel Wire)
(from Roof Wire) 2 2
30A PWR
(for High Current)
1 2 3
5F
4 5 6 7 8
30A DEF
(for High Current)
(from Instrument
Panel Wire)
5L 5G
IG1 Relay 1 HTR Relay Flasher Relay

1
(from Engine Room Main Wire)

(from Engine Room Main Wire)
30
HIACE (EM04Z2E)
F
1
2
3
4
5
6
7
8
9
10
11
12
13
Integration Relay 14
15
16
17
18
19
20
21
22
23
24
25
26
5M 7 8 9 1011 12 1011 12 13 14 15 1617 18 6 7 8 9 10 6 7 8 9 10 11 12 13

12 1110 9 8 7
1 2 3 4 5 6 1 2 3 4 5 6 7 8 9 1 2 3 4 5 1 2 3 4 5
6 5 4 3 2 1
(from Instrument Panel Wire)
5S 5P 5Q
1 2 3 4 5 6 7 8 9 1 2 3 4 5 1 2 3 4 5
6 7 8 9 10111213
1011121314 15161718 6 7 8 9 10
(from Instrument Panel Wire) (from Instrument Panel Wire) (from Instrument Panel Wire)
31
HIACE (EM04Z2E)
F RELAY LOCATIONS
: Instrument Panel J/B Left Side of Instrument Panel (See Page 21)
10A
TAIL
10A
PANEL
10A
25A A/C
WIP
15A
RR WIP-WSH
20A
WSH
7.5A
ECU-IG
10A
GAUGE 15A
7.5A CIG
OBD 7.5A
10A ACC
STOP
10A
30A ELS
DOOR
15A
RR HTR 15A
RR FOG
15A
FR FOG 15A
30A IGN
AM1 10A
MET IGN
32
HIACE (EM04Z2E)
Memo
33
HIACE (EM04Z2E)
F RELAY LOCATIONS
[Instrument Panel J/B Inner Circuit]
1 5E
19 5E 19 5A
11 5D 12 5A
3 5A T-LP Relay 15 5B
10A TAIL
1 5G 4 5E
16 5B 10A PANEL
6 5P
18 5H
2 5Q
9 5S
7 5P
4 5J
8 5Q
18 5S
8 5P
6 5E
9 5P
2 5B
6 5Q
24 5A
10 5P
4 5A
9 5Q
7 5Q
18 5E
6 5K
8 5S PWR Relay
1 2
3 5P 36 5B
30A PWR
4 5P
30 5B
5 5P
5 5K 11 5B
15 5E
18 5B
8 5E
14 5S 10A ELS
DEF Relay 11 5M
32 5E 1 2
2 5F
10 5D 30A DEF
12 5Q 4 5Q
15A FR FOG
4 5M
13 5Q
25 5B 30A DOOR
1 5H
7 5E
13 5E 2 5J
4 5H 30A AM1
1 5F
(Cont. Next Page)
34
HIACE (EM04Z2E)
F
(Cont’d)
10A STOP
3 5J
7.5A OBD
5 5S
30 5E
2 5M
14 5E 15A RR FOG
8 5M
28 5A
6 5M
12 5E
15A RR HTR
7 5M 9 5M
1 5K
5 5M
1 5A
9 5C
1 5S
15 5S
1 5C
4 2 5E
3 5
7 5F 1 5L
1 2
5 5Q 13 5A
31 5B HTR Relay
16 5S 14 5B
2 1
15 5A LR IG 13 5S
4 3
1 5J +B LL 27 5A
5 6
11 5S EL ER 12 5S
8 7
17 5S EHW GND
Flasher Relay
7 5S
Noise Filter
7 5B
5 3 7.5A ECU-IG
11 5C
2 1
3 5F
IG1 Relay
25A WIP
2 5H
20A WSH
12 5B
1 5P
10A GAUGE
2 5P
(Cont. Next Page)
35
HIACE (EM04Z2E)
F RELAY LOCATIONS
[Instrument Panel J/B Inner Circuit]
(Cont’d)
9 5H
15A RR WIP-WSH
10 5A
11 5Q
10 5Q
1 5Q
28 5E
27 5B
10 5S
10A A/C
10 5M
8 5F
8 5A RR HTR Relay
25 5E 10 5H
6 5D 13 5D
7 5C
1 5D
21 5E
15A IGN
9 5E 4 5F
16 5E
10A MET IGN
1 5M
12 5M 5 5F
15A CIG
3 5Q
7.5A ACC
4 5S
6 5S
10 5C
(Cont. Next Page)
36
HIACE (EM04Z2E)
F
(Cont’d)
3 5H
26 5B
3 5E
19 25 1 4 5
3 5S 12 5D
TRLY HAZ GND ALTB SIG 20
31 5E PCTY 10 5E
7 5H 7 5D
26
23 5B DCTY 27 5E
10
5 5B UL1 5 5D
2 5K 35 5B
5 5H 17 5H
6 5H 17 5E
24 5B 13 5B
12
6 5B L1 3 5D
6
33 5B ECUB 2 5S
25 5A 12 5H
2
26 5E ACT+ 15 5C
13 5H
Integration Relay
24 5E 9 5D
9
14 5D KSW 14 5H
2 5D 4 5B
2 5C 22 5B
16
17 5B UL2 22 5A
32 5B 34 5B
29 5A
3
18 5A ACT- 11 5E
30 5A 7 5A
9 5A 3 5B
22 14
8 5D RCTY L2 21 5B
37
HIACE (EM04Z2E)
F RELAY LOCATIONS
LHD : Instrument Panel Reinforcement LH (See Page 21)
: Center J/B
RHD : Instrument Panel Reinforcement RH (See Page 21)
Black
6B
1 2 3 4
5 6 7 8 9 10
6A
1 2 3 3 2 1 4 3 2 1
4 5 6 7 8 8 7 6 5 4 10 9 8 7 6 5 (from Instrument Panel Wire)
Gray
6C
10 9 8 7 6 5 4 3 2 1 1 2 3 4 5 6 7 8 9 10
22 21 20 19 18 17 16 15 14 13 12 11 11 12 13 14 15 16 17 18 19 20 21 22
Black
6D
1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18 19 20 20 19 18 17 16 15 14 13 12 11 10

10 9 8 7 6 5 4 3 2 1 6E 1 2 3 4 5 6 7 8 9 10
22 21 20 19 18 17 16 15 14 13 12 11 11 12 13 14 15 16 17 18 19 20 21 22
Gray (from Instrument Panel Wire)

6F
1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18 19 20 20 19 18 17 16 15 14 13 12 11 10
38
HIACE (EM04Z2E)
Memo
39
HIACE (EM04Z2E)
F RELAY LOCATIONS
[Center J/B Inner Circuit]
1 6A 14 6C
2 6A 15 6C
3 6A 16 6C
4 6A 17 6C
5 6A 18 6C
6 6A 19 6C
7 6A 20 6C
8 6A 21 6C
1 6B 22 6C
2 6B 6 6D
3 6B 7 6D
4 6B 8 6D
5 6B 9 6D
6 6B 1 6D
7 6B 2 6D
8 6B 3 6D
9 6B 4 6D
10 6B 5 6D
1 6C 13 6D
2 6C 14 6D
3 6C 15 6D
4 6C 16 6D
5 6C 17 6D
6 6C 18 6D
7 6C 19 6D
8 6C 20 6D
9 6C 10 6D
10 6C 11 6D
11 6C 12 6D
12 6C
13 6C
(Cont. Next Page)
40
HIACE (EM04Z2E)
F
(Cont’d)
4 6E 1 6F
5 6E 2 6F
6 6E 3 6F
7 6E 4 6F
8 6E 5 6F
9 6E 6 6F
10 6E 7 6F
1 6E 8 6F
2 6E 9 6F
3 6E 10 6F
20 6E 11 6F
21 6E 12 6F
22 6E 13 6F
17 6E 14 6F
18 6E 15 6F
19 6E 16 6F
14 6E 17 6F
15 6E 18 6F
16 6E 19 6F
11 6E 20 6F
12 6E
13 6E
41
HIACE (EM04Z2E)
F RELAY LOCATIONS
Junction Connector (CAN) Instrument Panel J/B RH Side (See Page 21)
H3 H4 H5
2 2 2
H6
1 1 1
1
1 1
1 1 1 2 ST-Plug
2 2 2 3
42
HIACE (EM04Z2E)
F
[Junction Connector (CAN) Inner Circuit]
H3(A), H4(B), H5(C), H6(D)

Junction Connector
2
A
2
B
2
C
ST-Plug
3
1 2 1 1
A D
1
B
1
C
43
HIACE (EM04Z2E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[LHD : 2TR-FE]
(A/T) (M/T) (M/T) (A/T)
D23 D40 D39 D37 D36 D35 D38 D35 D38 D42 D41 D22 D27 D32 D21 D26 E1 D25
E2
D33
D29
D34
g1
D30
D28
B12
D11
B16
D24
B14
D19
B17
D17
B9
D31
B7
D16
D3
D13
D1
B20
D44 D43 B18 D5 D7 D6 D9 D20 m1 B27 m2 B28 B29 B19 B36 B35 D10
B7 Engine ECU D22 Ignition Coil (No.3)

B9 Engine ECU D23 Ignition Coil (No.4)
B12 Air Injection Control Driver D24 Fuel Injector (No.1)
B16 A/C Magnetic Valve (Rear A/C) D26 Fuel Injector (No.3)
B17 Air Pump D27 Fuel Injector (No.4)
B18 Speed Sensor (Front RH) D28 VSV (Purge)
B19 Skid Control ECU with Actuator D29 Throttle Body Assembly
B20 Speed Sensor (Front LH) D30 Air Switching Valve
B27 Cooling Fan ECU No.1 D31 Variable Resistor
B28 Cooling Fan ECU No.2 D32 Water Temp. Sensor (Engine Coolant)
B29 Water Temp. Sensor (Radiator) D33 Air Fuel Ratio Sensor (Bank 1 Sensor 1)
B35 Junction Connector D34 Heated Oxygen Sensor (Bank 1 Sensor 1)
B36 Junction Connector D35 Heated Oxygen Sensor (Bank 1 Sensor 2)
D36 Back-Up Lamp SW
D1 Engine ECU D37 Park/Neutral Position SW
D3 Engine ECU D38 Speed Sensor
D5 Alternator D39 A/T Fluid Temp. Sensor
D6 Alternator D40 Transmission Revolution Sensor (Input)
D7 Engine Oil Pressure SW D41 ECT Solenoid
D9 Noise Filter (Ignition) D42 Transmission Revolution Sensor (Output)
D10 Camshaft Position Sensor D43 Junction Connector
D11 Engine Oil Level Sensor D44 Junction Connector
D13 A/C Compressor
D16 Power Steering Oil Pressure SW E1 Starter
D17 Crankshaft Position Sensor E2 Starter
D19 Camshaft Timing Oil Control Valve
D20 Ignition Coil (No.1) g1 Knock Control Sensor (Bank 1)
D21 Ignition Coil (No.2)
m1 Cooling Fan ECU No.1
Cooling Fan Motor No.1
44
HIACE (EM04Z2E)
G
[LHD : 2KD-FTV]
(M/T) (A/T)
D25 D26 D27 D56 D37 D36 D38 D38 D42 D41 D40 D53 D55 D7 D51
E1
* 1:From Oct. 2006 Production
* 2:Before Oct. 2006 Production D52
B13
D49
B15
E2
B16
B30
B18
D50
B9
B21
B38
D48
B7 (*2)
D12
D3 (*1)
D12
D1
D47
B39
D46
D10
D44 D43 D5 D14 D6 D32 B37 m1 B29 B27 m2 B28 B36 B35 B19 D24 B20 D17 D45
B7 Engine ECU D25 Fuel Injector (No.2)

B13 Injector Driver (EDU) D27 Fuel Injector (No.4)
B15 Injector Driver (EDU) D32 Water Temp. Sensor (Engine Coolant)
B16 A/C Magnetic Valve (Rear A/C) D36 Back-Up Lamp SW
B18 Speed Sensor (Front RH) D37 Park/Neutral Position SW
B19 Skid Control ECU with Actuator D38 Speed Sensor
B20 Speed Sensor (Front LH) D40 Transmission Revolution Sensor (Input)
B21 Fuel Sedimentary Level Warning SW D41 ECT Solenoid
B27 Cooling Fan ECU No.1 D42 Transmission Revolution Sensor (Output)
B28 Cooling Fan ECU No.2 D43 Junction Connector
B29 Water Temp. Sensor (Radiator) D44 Junction Connector
B30 Fuel Filter Warning SW D45 Fuel Pressure Sensor
B35 Junction Connector D46 Fuel Temp. Sensor
B36 Junction Connector D47 Suction Control Valve
B37 Junction Connector D48 Throttle Body Assembly
B38 Junction Connector D49 Inlet Air Temp. Sensor (Intake Manifold)
B39 Junction Connector D50 Throttle Body Assembly
D51 Turbo Pressure Sensor
D1 Engine ECU D52 EGR Valve Position Sensor
D3 Engine ECU D53 Glow Plug
D5 Alternator D55 VRV (EGR)
D6 Alternator D56 A/T Fluid Temp. Sensor
D7 Engine Oil Pressure SW
D10 Camshaft Position Sensor E1 Starter
D12 Engine Oil Level Sensor E2 Starter
D14 A/C Compressor
D17 Crankshaft Position Sensor m1 Cooling Fan ECU No.1
D24 Fuel Injector (No.1) Cooling Fan Motor No.1
45
HIACE (EM04Z2E)
[LHD : 5L-E]
D12 D62 D57 D61 D58 D38 D36 D54 E2 E1 D63

* 2:Before Oct. 2006 Production
B18
B16
B10
B8
D4
B30
D2
B21
D43
D59
D18
D5 D6 D15 D8 B35 B36 m1 B27 m2 B28 B29 D32 D32 B19 B20 D46 D60
(*1) (*2)
B8 Engine ECU D15 A/C Compressor

B10 Engine ECU D18 Engine Speed Sensor
B16 A/C Magnetic Valve (Rear A/C) D32 Water Temp. Sensor (Engine Coolant)
B18 Speed Sensor (Front RH) D36 Back-Up Lamp SW
B19 Skid Control ECU with Actuator D38 Speed Sensor
B20 Speed Sensor (Front LH) D43 Junction Connector
B21 Fuel Sedimentary Level Warning SW D46 Fuel Temp. Sensor
B27 Cooling Fan ECU No.1 D54 Glow Plug
B28 Cooling Fan ECU No.2 D57 Manifold Absolute Pressure Sensor
B29 Water Temp. Sensor (Radiator) D58 Throttle Body Assembly
B30 Fuel Filter Warning SW D59 Spill Control Valve
B35 Junction Connector D60 Injection Pump Assembly
B36 Junction Connector D61 Timer Control Valve
D62 Crankshaft Position Sensor
D2 Engine ECU D63 Throttle Position SW
D4 Engine ECU
D5 Alternator E1 Starter
D12 Engine Oil Level Sensor m1 Cooling Fan ECU No.1
46
HIACE (EM04Z2E)
Memo
47
HIACE (EM04Z2E)
Position of Parts in Instrument Panel
[LHD]
(*3)
A10 A9 A11 A26 A12 B34 e1 e2 A8 A6 J1
* 1:2TR-FE, 2KD-FTV
* 2:5L-E
* 4:Before Oct. 2006 Production A7
A17
A1
A18
O3
T21
O2
T19
C3
T2 (*2)
A2
(*4)
T18
O1
(*3)
T20
A5
T3
A3
A24 (*1)
A2
T1
C4
A23 (*1)
A4
C1
A22 A25 C2 A19 A16 A14 A20 A15 A21 A13 B2 A26 B1 B3 B4 B5 B6
(*4)
A1 Turn Signal Lamp (Front RH) B1 Accelerator Position Sensor

A2 Inlet Air Temp. Sensor (Air Cleaner) B2 Stop Lamp SW
A3 Air Flow Meter B3 Parking Brake SW
A4 A/C Pressure Sensor No.1 B4 Airbag Sensor Assembly Center
A5 Pressure SW B5 Airbag Sensor Assembly Center
A6 Clearance Lamp (Front RH) B6 Airbag Sensor Assembly Center
A7 Headlamp (RH) B34 Junction Connector
A8 Headlamp Leveling Motor (RH)
A9 Brake Vacuum Warning SW C1 Ultrasonic Sensor No.1 (Front LH)
A10 Brake Fluid Level Warning SW C2 Fog Lamp (Front LH)
A11 Windshield Wiper Motor C3 Ultrasonic Sensor No.1 (Front RH)
A12 Airbag Sensor (Front RH) C4 Fog Lamp (Front RH)
A13 Airbag Sensor (Front LH)
A14 Ambient Temp. Sensor J1 Airbag Squib (Front Passenger's Airbag Assembly)
A15 Horn (Low)
A16 Horn (High) O1 Transmission Control ECU
A17 Windshield Washer Motor O2 Transmission Control ECU
A18 Rear Washer Motor O3 Transmission Control ECU
A19 Headlamp (LH)
A20 Headlamp Leveling Motor (LH) T1 Junction Connector
A21 Clearance Lamp (Front LH) T2 Junction Connector
A22 Cooling Fan Motor No.2 T3 Junction Connector
A23 Turn Signal Lamp (Front LH) T18 Diode (Door Courtesy No.7)
A24 Short Pin (Vacuum) T19 Diode (Door Courtesy No.9)
A25 Junction Connector T20 Diode (Door Courtesy No.10)
A26 A/C Pressure Sensor No.2 T21 Diode (Door Courtesy No.11)
e1 PTC Heater
e2 PTC Heater
48
HIACE (EM04Z2E)
G
[LHD]
H28 I9 H31 H32 H30 H20 I6 I4 I12 I13 H44 I1 I2 H16 H10 I11 I14 H17 H11 I10
I3
I8
* 1:2TR-FE, 2KD-FTV
I7 * 2:5L-E
* 5:w/ Engine Immobiliser
System
H46 * 6:w/o Engine Immobiliser
System
H35 (*1)
H18
H36 (*2)
H19
H45
H33
H39
H40
H7
H42
H41
H38
H37
H3
H4 H5 H6 H23 H24 H43 H25 H26 H27 H22 H21 H8 H13 H15 H12 H14 H1 H2 H34
(*6) (*5) (A/T) (M/T)
H1 Blower Resistor (Front A/C) H32 Airbag Squib (Steering Wheel Pad)
H2 Blower Motor (Front A/C) H33 Clearance Warning ECU
H3 Junction Connector H34 Fuse Box
H4 Junction Connector H35 Diode (Door Courtesy No.1)
H7 Integration Relay H38 Diode (Headlight)
H8 A/C Evaporator Temp. Sensor (Front A/C) H39 Diode (Automatic Light Control No.1)
H10 Room Lamp SW H40 Diode (Automatic Light Control No.2)
H11 Rear Blower SW (Main) H41 Junction Connector
H12 Cigarette Lighter H42 Junction Connector
H13 Ashtray Illumination H43 Transponder Key Amplifier
H14 Blower SW (Front A/C) H44 Transponder Key ECU
H15 Clearance Warning Indicator H45 Diode (Door Courtesy No.8)
H16 A/C SW H46 Junction Connector
H17 Rear Window Defogger SW
H18 A/C Amplifier I1 Radio Receiver Assembly
H19 A/C Amplifier I2 Radio Receiver Assembly
H20 Combination Meter I3 Rear Fog Lamp SW
H21 A/T Shift Lever Illumination I4 Hazard Warning Signal SW
H22 Shift Lock Control ECU I6 Idle-Up SW
H23 DLC3 I7 Door Lock Control SW
H24 Ignition Key Cylinder Lamp I8 Outer Mirror SW
H25 Ignition SW I9 Headlamp Leveling SW
H26 Unlock Warning SW I10 Automatic Light Control Sensor
H27 Unlock Warning SW I11 Junction Connector
H28 Combination SW I12 Junction Connector
H30 Combination SW I13 Junction Connector
H31 Spiral Cable I14 Junction Connector
49
HIACE (EM04Z2E)
Position of Parts in Body
[LHD]
(*2) (*1) (*2) (*1)
T6 T4 T5 K2 B26 K4 K3 K6 K1 B25 M1 M2 T11 T7 T8
L3 (*2)
T12
L5 (*1)
T13
L4
L1
L2
R2
B22
B23
B24
* 1:w/ Map Lamp

* 2:w/o Map Lamp
* 3:Standard Body Standard Roof
* 4:Except *3
N1 B32 B33 T10 T9 M3 T17 T15 T14 T16
(*3) (*4)
B22 Door Courtesy SW (Front LH) M1 Slide Door Control Junction (Male RH)
B23 Front Seat Outer Belt (LH) M2 Door Control Relay (RH)
B24 Blower SW (Rear Heater) M3 Step Lamp (RH)
B25 Front Seat Outer Belt (RH)
B26 Door Courtesy SW (Front RH) N1 Slide Door Control Junction (Male LH)
B32 Door Control Relay (LH)
B33 Step Lamp (LH) R2 Front Seat Inner Belt (Driver's Side)
K1 Door Lock Assembly (Front RH) T4 Room Lamp (Front)

K2 Speaker (Front Door RH) T5 Map Lamp
K3 Outer Rear View Mirror (RH) T6 Diode (Door Courtesy No.4)
K4 Power Window Regulator Motor (Front RH) T7 Room Lamp (Center)
K6 Power Window SW (Front RH) T8 Room Lamp (Center)
T9 Diode (Door Courtesy No.5)
L1 Door Lock Assembly (Front LH) T10 Speaker (Roof LH)
L2 Speaker (Front Door LH) T11 Speaker (Roof RH)
L3 Outer Rear View Mirror (LH) T12 Room Lamp (Rear)
L4 Power Window Regulator Motor (Front LH) T13 Room Lamp (Rear)
L5 Power Window Master SW T14 Junction Connector
T15 Junction Connector
T16 Rear Combination Lamp (LH)
50
HIACE (EM04Z2E)
G
[LHD]
j5 j6 b2 X2 d1
U2
d2
j2
b1
j1
X1
j3
a3
U1
a1
a2
n1
W4
W3
* 5:2KD-FTV, 5L-E
* 6:2TR-FE
Y3 Y2 k1 k2 h1 h2 Y1 n2 W1 W2 a4
(*5) (*6)
U1 Rear Combination Lamp (RH) b1 Rear Window Defogger

U2 Junction Connector b2 Rear Window Defogger
W1 Ultrasonic Sensor No.1 (Rear LH) d1 Center Stop Lamp

W2 Ultrasonic Sensor No.2 (LH) d2 Rear Wiper Motor
W3 Ultrasonic Sensor No.2 (RH)
W4 Ultrasonic Sensor No.1 (Rear RH) h1 Fuel Sender Gage
h2 Fuel Suction Pump and Gage Assembly
X1 Speaker (Rear RH)
X2 Door Courtesy SW (Slide Door RH) j1 Blower Motor (Rear A/C LH)
j2 Blower Resistor (Rear A/C)
Y1 Speaker (Rear LH) j3 Blower SW (Rear A/C)
Y2 Door Control Receiver j5 A/C Evaporator Temp. Sensor (Rear A/C)
Y3 Door Courtesy SW (Slide Door LH) j6 Blower Motor (Rear A/C RH)
a1 Junction Connector k1 Blower Motor (Rear Heater)

a2 Back Door Courtesy SW k2 Blower Resistor (Rear Heater)
a3 Back Door Lock Assembly
a4 License Plate Lamp n1 Speed Sensor (Rear LH)
n2 Speed Sensor (Rear RH)
51
HIACE (EM04Z2E)
[RHD : 2TR-FE]
(A/T) (M/T) (M/T) (A/T)
D34 D33 D39 D37 D35 D36 D38 D35 D38 D42 D41 D40 D23 D22 D27 D32 D21 D26 E1 D25
D30
E2
B44
D29
D7
g1
B16
D28
B12
D11
B14
D24
B17
D19
B9
D31
B7
D17
D3
D16
D1
D13
B11
D44 D43 B18 D5 D6 D9 D20 m1 B27 m2 B28 B29 B19 B36 B35 D10 B20

B11 Front Seat Inner Belt (Driver's Side) D26 Fuel Injector (No.3)
B14 Air Injection Control Driver D28 VSV (Purge)
B16 A/C Magnetic Valve (Rear A/C) D29 Throttle Body Assembly
B17 Air Pump D30 Air Switching Valve
B18 Speed Sensor (Front RH) D31 Variable Resistor
B19 Skid Control ECU with Actuator D32 Water Temp. Sensor (Engine Coolant)
B20 Speed Sensor (Front LH) D33 Air Fuel Ratio Sensor (Bank 1 Sensor 1)
B27 Cooling Fan ECU No.1 D34 Heated Oxygen Sensor (Bank 1 Sensor 1)
B28 Cooling Fan ECU No.2 D35 Heated Oxygen Sensor (Bank 1 Sensor 2)
B29 Water Temp. Sensor (Radiator) D36 Back-Up Lamp SW
B35 Junction Connector D37 Park/Neutral Position SW
B36 Junction Connector D38 Speed Sensor
B44 Option Connector (TVSS Siren) D39 A/T Fluid Temp. Sensor
D40 Transmission Revolution Sensor (Input)
D1 Engine ECU D41 ECT Solenoid
D3 Engine ECU D42 Transmission Revolution Sensor (Output)
D5 Alternator D43 Junction Connector
D6 Alternator D44 Junction Connector
D9 Noise Filter (Ignition) E1 Starter
D10 Camshaft Position Sensor E2 Starter
D11 Engine Oil Level Sensor
D13 A/C Compressor g1 Knock Control Sensor (Bank 1)
D16 Power Steering Oil Pressure SW
D17 Crankshaft Position Sensor m1 Cooling Fan ECU No.1
D19 Camshaft Timing Oil Control Valve Cooling Fan Motor No.1
D20 Ignition Coil (No.1) m2 Cooling Fan ECU No.2
D21 Ignition Coil (No.2) Cooling Fan Motor No.1
52
HIACE (EM04Z2E)
Memo
53
HIACE (EM04Z2E)
[RHD : 1KD-FTV, 2KD-FTV]
B18 B44 D25 D26 D27 D7
(*1)
B42 * 1:1KD-FTV
* 2:2KD-FTV
(*2) * 3:From Oct. 2006 Production
B13 * 4:Before Oct. 2006 Production
(*1)
B41
(*2)
B15
B16
B30
(*1)
B40
B21
(*4)
B9
D12
B7 (*3)
D12
D3
D10
D1
B38
B39
B11
D5 D14 D6 B37 B29 B27 B28 B36 B35 B19 D24 B20 D17
B7 Engine ECU D1 Engine ECU

B9 Engine ECU D3 Engine ECU
B11 Front Seat Inner Belt (Driver's Side) D5 Alternator
B13 Injector Driver (EDU) D6 Alternator
B15 Injector Driver (EDU) D7 Engine Oil Pressure SW
B16 A/C Magnetic Valve (Rear A/C) D10 Camshaft Position Sensor
B18 Speed Sensor (Front RH) D12 Engine Oil Level Sensor
B19 Skid Control ECU with Actuator D14 A/C Compressor
B20 Speed Sensor (Front LH) D17 Crankshaft Position Sensor
B21 Fuel Sedimentary Level Warning SW D24 Fuel Injector (No.1)
B27 Cooling Fan ECU No.1 D25 Fuel Injector (No.2)
B28 Cooling Fan ECU No.2 D26 Fuel Injector (No.3)
B29 Water Temp. Sensor (Radiator) D27 Fuel Injector (No.4)
B30 Fuel Filter Warning SW
B35 Junction Connector
B40 Injector Driver (EDU)
B44 Option Connector (TVSS Siren)
54
HIACE (EM04Z2E)
G
(M/T) (A/T) (*1) (*2) (*1)
D68 D40 D56 D37 D36 D38 D38 D42 D41 D53 D69 D55 D67 D51 D51 D52 E1
(*2)
* 1:1KD-FTV D52
* 2:2KD-FTV
D49
D50
E2
D48
D64
D47
D46
D44 D43 D66 D65 D32 m1 m2 D45
D32 Water Temp. Sensor (Engine Coolant) E1 Starter

D36 Back-Up Lamp SW E2 Starter
D37 Park/Neutral Position SW
D38 Speed Sensor m1 Cooling Fan ECU No.1
D40 Transmission Revolution Sensor (Input) Cooling Fan Motor No.1
D41 ECT Solenoid m2 Cooling Fan ECU No.2
D42 Transmission Revolution Sensor (Output) Cooling Fan Motor No.1
D43 Junction Connector
D44 Junction Connector
D45 Fuel Pressure Sensor
D46 Fuel Temp. Sensor
D47 Suction Control Valve
D48 Throttle Body Assembly
D49 Inlet Air Temp. Sensor (Intake Manifold)
D50 Throttle Body Assembly
D51 Turbo Pressure Sensor
D52 EGR Valve Position Sensor
D53 Glow Plug
D55 VRV (EGR)
D56 A/T Fluid Temp. Sensor
D64 Pressure Discharge Valve
D65 Turbocharger Variable Nozzle Motor Assembly
D66 Turbocharger Variable Nozzle Motor Assembly
D67 Swirl Control Valve
D68 VSV (EGR Cut)
D69 Fuel Pressure Sensor
55
HIACE (EM04Z2E)
[RHD : 5L-E]
D12 D62 D61 D57 D58 D38 D36 D54 E2 E1 D63

B18
B16
B30
B10
B21
B8
D59
D4
D18
D2
D43
B11
D5 D6 D15 D8 B35 B36 m1 B27 m2 B28 B29 D32 B19 D32 B20 D46 D60
(*1) (*2)
B8 Engine ECU D15 A/C Compressor

B10 Engine ECU D18 Engine Speed Sensor
B11 Front Seat Inner Belt (Driver's Side) D32 Water Temp. Sensor (Engine Coolant)
B16 A/C Magnetic Valve (Rear A/C) D36 Back-Up Lamp SW
B18 Speed Sensor (Front RH) D38 Speed Sensor
B19 Skid Control ECU with Actuator D43 Junction Connector
B20 Speed Sensor (Front LH) D46 Fuel Temp. Sensor
B21 Fuel Sedimentary Level Warning SW D54 Glow Plug
B27 Cooling Fan ECU No.1 D57 Manifold Absolute Pressure Sensor
B28 Cooling Fan ECU No.2 D58 Throttle Body Assembly
B29 Water Temp. Sensor (Radiator) D59 Spill Control Valve
B30 Fuel Filter Warning SW D60 Injection Pump Assembly
B35 Junction Connector D61 Timer Control Valve
B36 Junction Connector D62 Crankshaft Position Sensor
D63 Throttle Position SW
D2 Engine ECU
D4 Engine ECU E1 Starter
D6 Alternator
D8 Engine Oil Pressure SW m1 Cooling Fan ECU No.1
D12 Engine Oil Level Sensor Cooling Fan Motor No.1
56
HIACE (EM04Z2E)
G
[RHD]
I10 I14 I13 I12 I11 I17 I1 I2 I5
* 7:w/ Power Slide Door

* 8:w/o Power Slide Door
I19
I3
I6
I18
(*8)
I7
(*7)
I15
I8
I16
I1 Radio Receiver Assembly I12 Junction Connector

I2 Radio Receiver Assembly I13 Junction Connector
I3 Rear Fog Lamp SW I14 Junction Connector
I5 Room Lamp SW I15 Power Slide Door Control SW
I6 Idle-Up SW I16 Power Slide Door Main SW
I7 Door Lock Control SW I17 Radio Receiver Assembly
I8 Outer Mirror SW I18 Radio Receiver Assembly
I10 Automatic Light Control Sensor I19 Option Connector (TVSS Indicator Lamp)
I11 Junction Connector
57
HIACE (EM04Z2E)
[RHD]
* 1:2TR-FE, 1KD-FTV, 2KD-FTV J1 A18 A17 A11 O3 A10 A9
T21
* 2:5L-E
* 3:1KD-FTV
T19 * 4:Except *3
T3 O2
T1 A12
T2 A6
(*5)
T20 A7
(*6)
T18 B1
A24 A1
A23 B2
(*2)
A22 A2
A25 C3
C1 C4
(*3)
A27
A19 A21 e1 e2 C2 B34 A16 A14 A13 A15 B4 B5 B6 B3 B43 O1 A4 A4 A5 A3 A2

(*1) (*3) (*4) (*4) (*1)
A1 Turn Signal Lamp (Front RH) B1 Accelerator Position Sensor

A2 Inlet Air Temp. Sensor (Air Cleaner) B2 Stop Lamp SW
A3 Air Flow Meter B3 Parking Brake SW
A4 A/C Pressure Sensor No.1 B4 Airbag Sensor Assembly Center
A5 Pressure SW B5 Airbag Sensor Assembly Center
A6 Clearance Lamp (Front RH) B6 Airbag Sensor Assembly Center
A7 Headlamp (RH) B34 Junction Connector
A9 Brake Vacuum Warning SW B43 Turbo Motor Driver
A10 Brake Fluid Level Warning SW
A11 Windshield Wiper Motor C1 Ultrasonic Sensor No.1 (Front LH)
A12 Airbag Sensor (Front RH) C2 Fog Lamp (Front LH)
A13 Airbag Sensor (Front LH) C3 Ultrasonic Sensor No.1 (Front RH)
A14 Ambient Temp. Sensor C4 Fog Lamp (Front RH)
A15 Horn (Low)
A16 Horn (High) J1 Airbag Squib (Front Passenger's Airbag Assembly)
A17 Windshield Washer Motor
A18 Rear Washer Motor O1 Transmission Control ECU
A19 Headlamp (LH) O2 Transmission Control ECU
A21 Clearance Lamp (Front LH) O3 Transmission Control ECU
A22 Cooling Fan Motor No.2
A23 Turn Signal Lamp (Front LH) T1 Junction Connector
A24 Short Pin (Vacuum) T2 Junction Connector
A25 Junction Connector T3 Junction Connector
A27 Air Flow Meter T18 Diode (Door Courtesy No.7)
e1 PTC Heater
e2 PTC Heater
58
HIACE (EM04Z2E)
G
[RHD]
(*1) (*2)
H35 H45 H48 H7 H51 H11 H44 H16 H9 H49 H18 H19 H33 H20 H29 H47
H37
H38
H46
H39
H36
H50
H41
(A/T)
H26
H40
(M/T)
H27
H3
(*10)
H24
H4
(*9)
H43
H5
H6
* 1:2TR-FE, 1KD-FTV,
H8 2KD-FTV
* 2:5L-E
* 9:w/ Engine
H2 Immobiliser System
* 10:w/o Engine
Immobiliser System
H34 H42 H15 H12 H1 H14 H17 H13 H22 H21 H30 H32 H31 H25 H23
H1 Blower Resistor (Front A/C) H27 Unlock Warning SW

H2 Blower Motor (Front A/C) H29 Combination SW
H3 Junction Connector H30 Combination SW
H4 Junction Connector H31 Spiral Cable
H5 Junction Connector H32 Airbag Squib (Steering Wheel Pad)
H6 Junction Connector H33 Clearance Warning ECU
H7 Integration Relay H34 Fuse Box
H8 A/C Evaporator Temp. Sensor (Front A/C) H35 Diode (Door Courtesy No.1)
H9 Hazard Warning Signal SW H36 Diode (Door Courtesy No.2)
H11 Rear Blower SW (Main) H37 Diode (Door Courtesy No.3)
H12 Cigarette Lighter H38 Diode (Headlight)
H13 Ashtray Illumination H39 Diode (Automatic Light Control No.1)
H14 Blower SW (Front A/C) H40 Diode (Automatic Light Control No.2)
H15 Clearance Warning Indicator H41 Junction Connector
H16 A/C SW H42 Junction Connector
H17 Rear Window Defogger SW H43 Transponder Key Amplifier
H18 A/C Amplifier H44 Transponder Key ECU
H19 A/C Amplifier H45 Diode (Door Courtesy No.8)
H20 Combination Meter H46 Junction Connector
H21 A/T Shift Lever Illumination H47 Diode (Power Slide Door)
H22 Shift Lock Control ECU H48 Junction Connector
H23 DLC3 H49 Option Connector (TVSS ECU)
H24 Ignition Key Cylinder Lamp H50 Option Connector (Clearance Warning Buzzer)
H25 Ignition SW H51 Option Connector (Fuse Box)
H26 Unlock Warning SW
59
HIACE (EM04Z2E)
[RHD]
(*7) (*1) (*2) (*2 *8)(*1 *8) (*1) (*2)
T7 T5 T4 K2 B26 K4 K3 K5 K1 B25 M1 M2 T7 T8 T13 T12
T6
L6
L3
L4
L1
R1
L2
B22
B23
B24
* 1:w/ Map Lamp

* 2:w/o Map Lamp
* 3:Standard Body
Standard Roof
* 4:Except *3
* 7:Taxi
* 8:Except *7
N1 B32 B33 T9 M3 T17 T15 T14 T16
(*3) (*4)
B22 Door Courtesy SW (Front LH) M1 Slide Door Control Junction (Male RH)
B23 Front Seat Outer Belt (LH) M2 Door Control Relay (RH)
B24 Blower SW (Rear Heater) M3 Step Lamp (RH)
B25 Front Seat Outer Belt (RH)
B26 Door Courtesy SW (Front RH) N1 Slide Door Control Junction (Male LH)
B32 Door Control Relay (LH)
B33 Step Lamp (LH) R1 Front Seat Inner Belt (Front Passenger's Side)
K1 Door Lock Assembly (Front RH) T4 Room Lamp (Front)

K2 Speaker (Front Door RH) T5 Map Lamp
K3 Outer Rear View Mirror (RH) T6 Diode (Door Courtesy No.4)
K4 Power Window Regulator Motor (Front RH) T7 Room Lamp (Center)
K5 Power Window Master SW T8 Room Lamp (Center)
L1 Door Lock Assembly (Front LH) T12 Room Lamp (Rear)
L2 Speaker (Front Door LH) T13 Room Lamp (Rear)
L3 Outer Rear View Mirror (LH) T14 Junction Connector
L4 Power Window Regulator Motor (Front LH) T15 Junction Connector
L6 Power Window SW (Front LH) T16 Rear Combination Lamp (LH)
60
HIACE (EM04Z2E)
G
[RHD]
j5 j6 b2 X2 d1

* 6:2TR-FE
U2
d2
b1
j2
X1
j1
a3
j3
U1
p4
a1
p5
a2
p6
n1
p3
W4
p2
W3
q6
p1 Y3 q1 q2 q5 q3 q4 Y2 h1 h2 Y1 n2 Y4 W1 W2 k1 k2 a4
(*5) (*6)
U1 Rear Combination Lamp (RH) j1 Blower Motor (Rear A/C LH)

U2 Junction Connector j2 Blower Resistor (Rear A/C)
j3 Blower SW (Rear A/C)
W1 Ultrasonic Sensor No.1 (Rear LH) j5 A/C Evaporator Temp. Sensor (Rear A/C)
W2 Ultrasonic Sensor No.2 (LH) j6 Blower Motor (Rear A/C RH)
W3 Ultrasonic Sensor No.2 (RH)
W4 Ultrasonic Sensor No.1 (Rear RH) k1 Blower Motor (Rear Heater)
k2 Blower Resistor (Rear Heater)
X1 Speaker (Rear RH)
X2 Door Courtesy SW (Slide Door RH) n1 Speed Sensor (Rear LH)
Y1 Speaker (Rear LH)
Y2 Door Control Receiver p1 Slide Door Lock Assembly
Y3 Door Courtesy SW (Slide Door LH) p2 Door Opening Relay
Y4 Option Connector (Clearance Warning ECU) p3 Door Control SW
p4 Slide Door Handle SW
a1 Junction Connector p5 Slide Door Lock Remote Control Assembly
a2 Back Door Courtesy SW p6 Power Slide Door Sensor
a3 Back Door Lock Assembly
a4 License Plate Lamp q1 Slide Door Motor Assembly
q2 Slide Door Warning Buzzer
b1 Rear Window Defogger q3 Door Control Relay (Power Slide Door)
b2 Rear Window Defogger q4 Door Control Relay (Power Slide Door)
q5 Slide Door Motor Assembly
d1 Center Stop Lamp q6 Step Lamp (LH)
d2 Rear Wiper Motor
h1 Fuel Sender Gage
61
HIACE (EM04Z2E)
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[LHD : 2TR-FE]
D2 D1 Sensor Wire Dg1 Engine No.2 Wire
Pillar No.1
Wire
Pillar No.2
MB1 Wire
B2
NB1
BD1 BE1
B1 B3
Engine Room
Main Wire
Engine Wire DB5 DB4 DB6 DB3 DB1
62
HIACE (EM04Z2E)
G
[LHD : 2KD-FTV]
Engine Wire Engine No.3 Wire D3 Engine No.2 Wire
Pillar No.1
Wire BE1
MB1
Pillar No.2
Wire
B2
NB1
BD1
B3
DO1
Engine Room
B1 Main Wire
Floor Wire
DB5 DB4 DB6 DB2 DB3 DB1
63
HIACE (EM04Z2E)
[LHD : 5L-E]
Engine No.3 Wire D4 Engine No.2 Wire BE1
Pillar No.1
Wire
Pillar No.2
Wire
MB1
NB1
B2
B3
B1
Engine Room
Main Wire
DB4 DB6 DB1 Engine Wire
64
HIACE (EM04Z2E)
Memo
65
HIACE (EM04Z2E)
[LHD]
HH1 Instrument Cowl to Head HJ1 Instrument Panel
Panel Wire Lamp Wire No.2 Wire
Roof Wire Instrument

Panel No.3
IH2 Wire
IH1 IH3
BT1
AB2
BT2
Floor Wire
AB1
HA1 Front Door

RH Wire
HA2
Front Door
LH Wire
Engine Room Engine Room

Main Wire HB4 HB3 CA1 HB2 HB1 No.4 Wire Heater Wire

H1 H2
B4
A2
A1
66
HIACE (EM04Z2E)
G
[LHD]
Instrument Cowl to Head Instrument Panel

* 1:Wide Body Panel Wire Lamp Wire No.2 Wire
* 2:Standard Body
Instrument
Panel No.3
Wire
Roof Wire
OB1
Engine Room
Main Wire
Front Door
LA1 RH Wire
Front Door
LH Wire
KA1
LA2
LA3
(*1) (*2) (*1) (*2)
Engine Room
No.4 Wire eB1 eB2 eB3 eB4 Heater Wire Floor Wire KA3 KA2
67
HIACE (EM04Z2E)
[LHD]
* 1:Standard Body Standard Roof TU1 TU2 TU3
* 2:Except *1 (*2) (*1)
Vj1
VB1 ZU1
RB1 db1
db2
UX1
Za1
dT1
BP2 BP1 BP3 kP1 Ph1 TY1 TY2 WS1 SP1 Pn1

Rear A/C Engine Room Front Door Pillar No.1 Rear Window Back Door
Sub Wire Main Wire RH Wire Wire No.1 Wire No.3 Wire
Roof Wire Roof No.2

Wire
Roof No.3
Wire Rear Window
No.1 Wire
Seat No.2
Wire Back Door
No.1 Wire
Engine Room Luggage Room

Main Wire No.2 Wire
a1
Front Door
LH Wire
Back Door
Pillar No.2 No.2 Wire
Wire
Skid Control
Sensor Wire
Luggage
Room Wire
Engine Room Luggage Room Rear A/C Y1 Frame No.3
Main Wire Frame Wire No.3 Wire Sub Wire Wire Fuel Tank Wire
68
HIACE (EM04Z2E)
Memo
69
HIACE (EM04Z2E)
[RHD : 2TR-FE]
D2 D1 Sensor Wire Dg1 Engine No.2

Wire
Pillar No.1
Wire
Pillar No.2
Wire
MB1
B2 NB1
BE1
BD1
B3
B1
Engine Room
Main Wire
Engine Wire DB5 DB4 DB6 DB3 DB1
70
HIACE (EM04Z2E)
G
Engine No.3 D3 Engine No.2

Wire Wire
* 1:1KD-FTV
Pillar No.1 * 2:2KD-FTV
Wire
MB1
Pillar No.2
Wire
B2
BD1
NB1
DB7
BE1
(*2)
DO1
(*1) B3
DO2
Engine Room
B1 Main Wire
Floor Wire
Engine Wire DB5 DB4 DB6 DB2 DB3 DB1
71
HIACE (EM04Z2E)
[RHD : 5L-E]
Engine No.3 D4 Engine No.2

Wire Wire
BE1
Pillar No.1 Pillar No.2

Wire Wire
MB1 NB1
B2
B3
B1
Engine Room
Main Wire
Engine Wire DB4 DB6 DB1
72
HIACE (EM04Z2E)
Memo
73
HIACE (EM04Z2E)
[RHD]
IH1 IH2 Instrument Panel HJ1 CA1 Cowl to Head
No.3 Wire Lamp Wire
Instrument
Panel Wire
Roof Wire
Instrument Panel
BT1 No.2 Wire
BT2 HH1
AB1 IH4
HA2 AB2
HB4 Engine Room
No.4 Wire
HB1
HB2
Front Door
RH Wire
Front Door
LH Wire
Floor Wire
Engine Room
Main Wire HB3 HA1 Heater Wire

H1 H2
B4
A1
A2
74
HIACE (EM04Z2E)
G
[RHD]
Instrument Panel Cowl to Head Instrument

No.3 Wire Lamp Wire Panel Wire
* 1:Wide Body
* 2:Standard Body
Roof Wire
Instrument Panel
Engine Room No.2 Wire
Main Wire
OB1
Front Door
LH Wire
Front Door
RH Wire
LA1
LA2 KA1
LA3 KA2
KA3
(*1) (*2) (*1) (*2)

Engine Room
Heater Wire eB1 eB2 eB3 eB4 No.4 Wire Floor Wire
75
HIACE (EM04Z2E)
[RHD]
TU1 TU2 TU3
* 1:Standard Body Standard Roof (*2) (*1)
* 2:Except *1
Vj1 ZU1
VB1 db1
RB1 db2
po1 dT1
Bq2 UX1
Bq1 Za1
kQ1
QP1
BP2 BP1 BP3 oq1 Ph1 TY1 TY2 WS1 SP1 Pn1

Rear A/C Pillar No.1 Wire Front Door Engine Room Rear Window Back Door
Sub Wire RH Wire Main Wire No.1 Wire No.3 Wire
Roof Wire
Roof No.3 Roof No.2
Wire Wire
Rear Window
Seat No.2 No.1 Wire
Wire Frame No.2
Wire
p1
Luggage Room
No.2 Wire
Front Door
LH Wire Back Door
No.1 Wire
Engine Room a1
Main Wire
Back Door
Pillar No.2 No.2 Wire
Wire
Rear A/C
Sub Wire
Slide Door
Wire Skid Control
Sensor Wire
Luggage Room
Wire
Engine Room Step Rear Frame Rear Door Luggage Room Y1 Frame No.3 Fuel Tank
Main Wire Floor LH Wire Wire No.2 Wire No.3 Wire Wire Wire
76
HIACE (EM04Z2E)
Memo
77
HIACE (EM04Z2E)
H SYSTEM CIRCUITS
HIACE
ELECTRICAL WIRING DIAGRAM
SYSTEM CIRCUITS
Page
ABS ...................................................................................................................... 220
Audio System ..................................................................................................... 248
Automatic Light Control .................................................................................... 156
Back-Up Light ..................................................................................................... 140
Charging (2TR-FE, 1KD-FTV, 2KD-FTV) ........................................................... 88
Charging (5L-E) .................................................................................................. 90
Cigarette Lighter ................................................................................................. 236
Clock .................................................................................................................... 250
Combination Meter ............................................................................................. 250
Cooling Fan (2TR-FE, 1KD-FTV, 2KD-FTV) ...................................................... 256
Cooling Fan (5L-E) ............................................................................................. 260
DLC3 .................................................................................................................... 124
Door Closer ......................................................................................................... 190
Door Lock Control (LHD) ................................................................................... 174
Door Lock Control (RHD) .................................................................................. 180
ECT and A/T Indicator (1KD-FTV, 2KD-FTV) .................................................... 212
ECT and A/T Indicator (2TR-FE) ........................................................................ 206
Engine Control (1KD-FTV, 2KD-FTV) ................................................................ 104
Engine Control (2TR-FE) ................................................................................... 94
Engine Control (5L-E) ........................................................................................ 114
Engine Immobiliser System (1KD-FTV, 2KD-FTV) .......................................... 122
Engine Immobiliser System (2TR-FE) .............................................................. 120
Front Air Conditioner (2TR-FE, 1KD-FTV, 2KD-FTV) ...................................... 264
Front Air Conditioner (5L-E) .............................................................................. 272
Front Fog Light ................................................................................................... 128
Front Wiper and Washer .................................................................................... 162
Headlight ............................................................................................................. 126
Headlight Beam Level Control .......................................................................... 160
Horn ..................................................................................................................... 238
Ignition ................................................................................................................ 92
Illumination ......................................................................................................... 146
Interior Light ....................................................................................................... 150
Key Reminder ..................................................................................................... 230
Light Auto Turn Off System .............................................................................. 156
Light Reminder ................................................................................................... 230
Multiplex Communication System (CAN) ........................................................ 282
Parking Assist (TOYOTA Parking Assist-Sensor) .......................................... 242
Power Slide Door ................................................................................................ 186
Power Source ..................................................................................................... 80
Power Window (LHD) ......................................................................................... 166
Power Window (RHD) ........................................................................................ 170
PTC Heater (2KD-FTV) ....................................................................................... 276
78
HIACE (EM04Z2E)
H
Page
Rear Air Conditioner .......................................................................................... 284
Rear Fog Light .................................................................................................... 130
Rear Window Defogger ...................................................................................... 240
Rear Wiper and Washer ..................................................................................... 164
Remote Control Mirror ....................................................................................... 234
Seat Belt Warning ............................................................................................... 232
Shift Lock ............................................................................................................ 228
SRS ...................................................................................................................... 223
Starting ................................................................................................................ 84
Stop Light ............................................................................................................ 138
Taillight ................................................................................................................ 142
Turn Signal and Hazard Warning Light ............................................................ 134
Wireless Door Lock Control (LHD) ................................................................... 194
Wireless Door Lock Control (RHD) ................................................................... 200
79
HIACE (EM04Z2E)
Power Source
30A AM2
1
1 2 W–R W–R W–R
2 HB2
30A D. C. C 15A RADIO
1 2 1 2 L–Y
2
30A RR DOOR 10A DOME
1 2 B–R 1 2 R
2 2 2
W
40A HEAD
HEAD Relay
1 2 W–R W–R 1 2 R–W
2 4 4
10A ECU–B W–R 3 5 W–L

4 4
1 2 W–R
2
10A ETCS
1 2 Y–B W–L
2
25A ABS SOL
1 2 W–R
2
140A ALT 30A RR CLR
2
40A ABS MTR Y
1C
1 2 W
2
50A FAN1 120A MAIN4
1
7. 5A ALT–S B–G
1G
1 2 P
2
50A FAN2 40A HTR
2
25A PSD B–R
1B
1 2 W
2
30A FAN3 50A PTC1
W
50A A/PUMP (∗1) 50A PTC2

80A GLOW (∗2)
FL MAIN
2. 0L
50A MAIN3
1 3
W W W
1D 1B
FL MAIN
3. 0W
Battery
80
HIACE (EM04Z2E)
∗ 1 : 2TR–FE
∗ 2 : 1KD–FTV, 2KD–FTV, 5L–E
W–R W–L
15A CIG
5 7. 5A ACC
ACC 3 R–B
5F
W–L 2 AM1 IG1 4 B–Y B–Y
ST1 1 R–W R–W
4 15A IGN
W–R 7 AM2 IG2 6 B–R
5F
15A HEAD LH ST2

10A MET IGN
1 2 L
4
H25
Ignition SW
15A HEAD RH
W–L 1 2 R
4 4
RR CLR Relay
2 1
7. 5A A/C NO. 3
Y Y 5 3 L 1 2 P
1 1 4 4
B–G B–G
4 7. 5A A/C
1 7
B–R 5 3 L 3 4 L–O
5L 5F
2 1 H34
15A A/F Fuse Box
1 2 HTR Relay
15A HAZ–HORN
1 2
20A EFI (∗1)

25A EFI (∗2)
1
W 1 2
1K
81
HIACE (EM04Z2E)
Power Source
W–L
30A AM1 1
W–L
5F
T–LP Relay
1 10A TAIL
B–G
5G
B–Y 10A PANEL
R–W
30A PWR
PWR Relay
1 2
12
W–B
5E
30A DEF
DEF Relay
10A ELS 7
1 2 W–B
5M
15A FR FOG
R–W
30A DOOR
9 HB2
10A STOP
B–G 7. 5A OBD
15A RR FOG
R–W
15A RR HTR
Noise Filter W–B
12
Connector
10A GAUGE
Junction
H41
7. 5A ECU–IG 1
5 3
B–Y
3 25A WIP
2 1
W–B
5F
IG1 Relay 20A WSH
15A RR WIP–WSH
10A A/C
7. 5A ST
W–B
W–B
R–W 1 2 B–W
4 4
H1 B3
82
HIACE (EM04Z2E)
: Parts Location
49 (LHD) 49 (LHD) 49 (LHD)
H25 H34 H41
59 (RHD) 59 (RHD) 59 (RHD)
: Relay Blocks
22 (*7)
1 Engine Room R/B No.1 (Engine Compartment Front)
23 (*8)
2 28 Engine Room R/B No.2 (Inside of Battery Room)
4 29 Instrument Panel R/B (Under the Glove Box)
: Junction Block and Wire Harness Connector

1B
1C
24
1D Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
1G
1K 25
5E 30 Engine Room Main Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5F 30 Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5G
30 Engine Room Main Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5L
5M 31 Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
: Connector Joining Wire Harness and Wire Harness

66 (LHD)
HB2 Instrument Panel Wire and Engine Room Main Wire (Near the Steering Column)
74 (RHD)
: Ground Points
62 (*1)
63 (*2)
64 (*3)
B3 Front Floor Panel Left
70 (*4)
71 (*5)
72 (*6)
66 (LHD)
H1 Instrument Panel Reinforcement
74 (RHD)
*1: LHD 2TR-FE *2: LHD 2KD-FTV *3: LHD 5L-E *4: RHD 2TR-FE *5: RHD 1KD-FTV, 2KD-FTV *6: RHD 5L-E
*7: 2TR-FE *8: 1KD-FTV, 2KD-FTV, 5L-E
83
HIACE (EM04Z2E)
Starting
R–W
R–W
ACC
9 HB2
W–L 2 AM1 IG1
ST1 1 R–W
1 5F
7 AM2 IG2
30A ST2 8
AM1
H25
R
Ignition SW
R
1 5G (∗3)
12 HB2
W–R
B–G
(∗3)
R
1 1G R
R
1 HB2 (∗1, ∗2)
W–R
4 4
120A
MAIN4
2 5 1
ST
2 Relay
3 2
140A 30A
ALT AM2
4 4
1
W–B
B
1 1D 2
W
1 BE1
FL MAIN FL MAIN
B
3. 0W 2. 0L
B–R
1 A (∗1)
B
1 B (∗7)
1 C (∗8)
Battery 1 D (∗9)
1 E (∗10) 1 G (∗1)
E1(A), (B), (C), (D), (E), (F),
1 F (∗11) 1 H (∗2, ∗3)

E2(G), (H)
M
Starter
W–B
B3
84
HIACE (EM04Z2E)
R–W
∗ 1 : 2TR–FE
R–W
∗ 2 : 1KD–FTV, 2KD–FTV
∗ 3 : 5L–E
4 ∗ 4 : 2TR–FE A/T, 1KD–FTV A/T, 2KD–FTV A/T
∗ 5 : 2TR–FE M/T, 1KD–FTV M/T, 2KD–FTV M/T
∗ 6 : Optitron Meter (Before Oct. 2006 Production)
1 ∗ 7 : 2KD–FTV A/T Except Cold Area Spec.
∗ 8 : 2KD–FTV A/T Cold Area Spec.
∗ 9 : 1KD–FTV, 2KD–FTV M/T Except Cold Area Spec.
7. 5A ∗10 : 5L–E Cold Area Spec.
ST ∗11 : 5L–E Except Cold Area Spec.
B34 4
Junction
Connector
R 22 16 R
(∗2 A/T)
(∗1, ∗2)
B–W
B–W
(∗3) (∗3)
19
7 11
Connector
13
Junction
10 B–W
R DB1
B34
(∗1, ∗2)
(∗1, ∗2) 9
(∗2 A/T)
(∗1, ∗2)
B–W
B–W
(∗1, ∗2)
B–W
(∗3)
R
3 DB3
B–W 12 DB1 4 OB1

(∗4)
B–W
B–W
(∗5)
(∗4)
Park/Neutral Position SW
R 4
(∗2 A/T)
(∗1, ∗2)
B–W
B–W
(∗4) L B
P
7 DB3
N
D37
5
(∗1, ∗2)
(∗1, ∗2)
(∗4)
R
B34 30 A (∗1)
Junction Connector 6 A (∗2) 12 C
B9(A), B10(E)
16 18
Transmission
NSW NSW
Control ECU
Engine ECU
O1(C)
21 20 19
STA STA
(∗2 A/T)
(∗1, ∗2)
12 A (∗1) 11 C
(∗6)
R
7 A (∗2)
11 E (∗3)
(∗2 A/T)
R
34 HB1
(∗6)
R
R 5 OB1
(∗1, ∗2)
(∗3)
Combination Meter
34
ST R
(∗2 A/T)
H20
85
HIACE (EM04Z2E)
Starting
: Parts Location
44 (*1) 44 (*1) 44 (*1)
A G
45 (*2) 52 (*4) 52 (*4)
B9 A
52 (*4) 45 (*2) 45 (*2)
B E2
54 (*5) 55 (*5) 46 (*3)
H
46 (*3) 45 (*2) 55 (*5)
B10 E C
56 (*6) 55 (*5) 56 (*6)
E1
48 (LHD) 45 (*2) 49 (LHD)
B34 D H20
58 (RHD) 55 (*5) 59 (RHD)
44 (*1) 46 (*3) 49 (LHD)
E H25
45 (*2) 56 (*6) 59 (RHD)
D37
52 (*4) 46 (*3) 48 (LHD)
F O1 C
55 (*5) 56 (*6) 58 (RHD)
: Relay Blocks

1D
24 Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
1G
5G 30 Engine Room Main Wire and Instrument Panel J/B (Left Side of Instrument Panel)

62 (*1)
63 (*2)
64 (*3)
BE1 Engine Room Main Wire and Engine No.2 Wire (LH Side Battery Room)
70 (*4)
71 (*5)
72 (*6)
62 (*1)
63 (*2)
DB1
70 (*4)
71 (*5)
Engine Wire and Engine Room Main Wire (Front Side of Engine Room R/B No.1)
62 (*1)
63 (*2)
DB3
70 (*4)
71 (*5)
66 (LHD)
HB1
74 (RHD)
Instrument Panel Wire and Engine Room Main Wire (Near the Steering Column)
66 (LHD)
HB2
74 (RHD)
67 (LHD) Floor Wire and Engine Room Main Wire (RH Side of Instrument Panel R/B)
OB1
75 (RHD) Floor Wire and Engine Room Main Wire (Near the Stop Lamp SW)
: Ground Points
62 (*1)
B3 63 (*2) Front Floor Panel Left
64 (*3)
86
HIACE (EM04Z2E)
: Ground Points
70 (*4)
72 (*6)
87
HIACE (EM04Z2E)
Charging (2TR-FE, 1KD-FTV, 2KD-FTV)
(IG) (IG)
10A 10A
MET IGN GAUGE
∗ 1 : 2TR–FE
∗ 3 : 2TR–FE, 1KD–FTV, RHD 2KD–FTV
∗ 4 : LHD 2KD–FTV 1 5M 2 5E
B–R
L–R
6
IG+
Charge
Combination
A/C Amplifier
Engine ECU
Meter
H20
D1(D)
H18
ALT ALT CHG–

37 10 D (∗1) 33
8 D (∗2)
B
W
36 HB1
14 HB1 6 DB3
B
W
(∗3)
W
1
10 B36
(∗4)
Junction
B
9 Connector
1 1A 2 2
P
B35
L–R
8
W
Junction B
2 Connector (∗3)
W
7. 5A ALT–S
140A ALT
4 DB3 (∗1)
5 DB3 (∗2) 2 DB3 1 DB3 5 DB4 1 DB6
1
L–R
W
B
P
1 1D 2
W
L–R
W
P
W
FL MAIN FL MAIN
3. 0W 2. 0L D5(A), D6(B)
1 B 3 B 4 B 2 B 1 A Alternator
S M L IG B
Battery
IC Regulator
88
HIACE (EM04Z2E)
: Parts Location
44 (*1) 45 (*2) 45 (*2)
45 (*2) D1 D 52 (*4) D6 B 52 (*4)
B35
52 (*4) 54 (*5) 54 (*5)
54 (*5) 44 (*1) 49 (LHD)
H18
44 (*1) 45 (*2) 59 (RHD)
D5 A
B36 52 (*4) 52 (*4) 49 (LHD)
H20
54 (*5) 54 (*5) 59 (RHD)
D1 D 44 (*1) D6 B 44 (*1)
: Relay Blocks

1A
1D

62 (*1)
63 (*2)
DB3
70 (*4)
71 (*5)
62 (*1)
63 (*2)
DB4 Engine Wire and Engine Room Main Wire (Front Side of Engine Room R/B No.1)
70 (*4)
71 (*5)
62 (*1)
63 (*2)
DB6
70 (*4)
71 (*5)
66 (LHD)
74 (RHD)
89
HIACE (EM04Z2E)
Charging (5L-E)
(IG) (IG)
10A 10A
MET IGN GAUGE
1 5M 2 5E
B–R
L–R
6
IG+
Charge
Combination
Meter
H20
CHG–
33
36 HB1
Engine ECU
B10(E)
ALT
22 E
W
B
W
P
1 1A 2 L–R
W
2
12 DB1 13 DB1
7. 5A ALT–S
140A ALT
8 DB1 5 DB4 1 DB6

W
W
P
L–R
1 1D 2
W
L–R
W
P
FL MAIN FL MAIN
3. 0W 2. 0L D5(A), D6(B)
1 B 3 B 4 B 2 B 1 A Alternator
S M L IG B
Battery
IC Regulator
90
HIACE (EM04Z2E)
: Parts Location
46 (*3) D5 A 56 (*6) 49 (LHD)
B10 E H20
56 (*6) 46 (*3) 59 (RHD)
D6 B
D5 A 46 (*3) 56 (*6)
: Relay Blocks

1A
1D

64 (*3)
DB1
72 (*6)
64 (*3)
72 (*6)
64 (*3)
DB6
72 (*6)
66 (LHD)
74 (RHD)
91
HIACE (EM04Z2E)
Ignition
ST2
17 HB2
H25
Ignition SW
B–R
4 DB1
B–R
B–R B–R B–R
B–R
1
D9
Noise Filter
(Ignition)
B–R
B–R
B–R
B–R
W–R
D20 D21 D22 D23

Ignition Coil Ignition Coil Ignition Coil Ignition Coil
1 (No. 1) 1 (No. 2) 1 (No. 3) 1 (No. 4)
1 HB2 +B +B +B +B
IGT1 IGF GND IGT2 IGF GND IGT3 IGF GND IGT4 IGF GND
W–R
3 2 4 3 2 4 3 2 4 3 2 4
2
W–R
W–R
W–R
W–R
L–W
Y–R
B–Y
R–L
BR
BR
BR
BR
2
BR BR BR
30A
AM2
BR
1
W–R W–R W–R
2
W–R
W
7
Connector
Junction
FL MAIN
D44
2. 0L
1
W–R
L–W
Y–R
B–Y
R–L
Battery 17 D 16 D 15 D 14 D 23 D
IGT1 IGT2 IGT3 IGT4 IGF1
BR
D1(D)
Engine ECU
D1
92
HIACE (EM04Z2E)
: Parts Location
44 (*1) 44 (*1) 44 (*1)
D1 D D21 D44
52 (*4) 52 (*4) 52 (*4)
44 (*1) 44 (*1) 49 (LHD)
D9 D22 H25
52 (*4) 52 (*4) 59 (RHD)
44 (*1) 44 (*1)
D20 D23
52 (*4) 52 (*4)
: Relay Blocks

62 (*1)
70 (*4)
66 (LHD)
74 (RHD)
: Ground Points
62 (*1)
D1 Engine Block
70 (*4)
93
HIACE (EM04Z2E)
Engine Control (2TR-FE)
(BAT) (BAT)
20A 15A
EFI A/F
2 2
7 AM2 IG2 6
MAIN A/F
ST2 Relay Relay
W–R
B–R
H25
Ignition SW
3 1J 2 1J 4 1J 1 1J 3 1I 2 1I 4 1I
C/OPN
Relay
W–B
W–B
G–Y
B–R
B–R
B–R
(∗4)
(∗4)
(∗4)
L
8 1J 7 1J 6 1J
B–R
B–R
L–Y
B–R
4 HB2
W–R
4 BP1
(∗4)
B–R
L
B–R
1 HB2
1 Ph1
Fuel Suction Pump and
11 DB1
W–R
B–R
3 DB1 4
Gage Assembly
2
Pump
(∗4)
M
L
2
B–R
h2
5
W–B
30A
AM2
3 Ph1
1
W–B
2
8 BP1
W
B–R
(∗4)
W–B
L–Y
FL MAIN
2. 0L B–R
B–R B–R
G–Y
W–B
B–R
Battery W–B W–B L

(∗4) (∗4)
W–B
B2
94
HIACE (EM04Z2E)
(BAT)
50A
A/PUMP
∗ 1 : Australia, Chile, China, Ecuador, Hong Kong, New Zealand, Thailand
∗ 2 : From Oct. 2006 Production
∗ 3 : Algeria, Costa Rica, El Salvador, Guatemala, Honduras, Mexico,
Nicaragua, Niger, Panama, Peru, South Africa, Vietnam
1 1E ∗ 4 : ∗1, ∗2 ∗3
B–R
B–R
B–W
B–R
(∗4)
B12(B), B14(A)
26 HB2 1 A Air Injection Control Driver
BATT
B–R
+B E W VP SIV DI SIP
5 B 1 B 6 B 2 A 3 B 2 B 4 B
B–R
W–R
B–W
B–R
(∗4)
(∗4)
(∗4)
(∗4)
(∗4)
(∗4)
(∗4)
BR
LG
B
11 BD1 2 BD1 14 BD1 13 BD1 15 BD1

W–R
(∗4)
(∗4)
(∗4)
LG
Y
B–W
(∗4)
(∗4)
BR
(∗4)
B
2
2
Air Switching
Air Pump
M
B17
Valve
D30
1
1
W–B
W–B
(∗4)
(∗4)
(∗4)
BR
3 W–R(∗4)
Connector
Junction
4
D43
LG(∗4)
1
Y(∗4)
W–B
B–R
(∗4)
(∗4)
L–Y L–Y
B–R B–R
B–R B–R
G–Y G–Y
B–R
L L
(∗4) (∗4)
W–B
W–B
(∗4)
(∗4)
D2 B2
95
HIACE (EM04Z2E)
(IG) (BAT)
15A 10A
IGN STOP
7 5C 9 5E 21 5E 3 5J 4 5J 6 5E
R–W
R–W
G–B
B–R
B–R
B–R
B–R
17 HB4 19 HB4
B–R B–R B–R
R–W
G–B
B–R
B–R
B–R
B–R
19
Connector
Junction
3 2
B35
Stop Lamp SW
1 1 1 1
20
Fuel Injector
Fuel Injector
Fuel Injector
Fuel Injector
(No. 1)
(No. 2)
(No. 3)
(No. 4)
B2
D24
D25
D26
D27
4 1
R–W
2 2 2 2
R–W
B–W
B–R
R–L
R
B
6 C 5 C 2 C 1 C 9 A 16 A 4 B
#1 #2 #3 #4 IGSW ST1– STP
B7(B), B9(A), D1(D), D3(C)
Engine ECU
AIRP AIDI AIRV FC BATT +B MREL PRG VG E2G THA
11 D 20 C 24 D 25 A 3 A 1 A 8 A 23 C 28 C 30 C 29 C
Y–R
Y–G
L–R
R
(∗4, ∗8)
W–R
G–Y
B–R
B–R
L–Y
(∗4)
(∗4)
(∗4)
LG
1 DB1 2 DB1 8 DB1 9 DB1

Y–G
Y–R
L–R
1
10 AB1 11 AB1 19 AB1 20 AB1
VSV (Purge)
Y–G
Y–R
L–R
R
D28
W–R(∗4)
3 2 4 5
2
LG(∗4) VG E2G THA E2
(∗4, ∗8)
Y(∗4)
B–R
+B
L–Y A3
1
Air Flow Meter
B–R
B–R
B–R 5 DB1
B–R B–R 3 AB1 Y–R

(∗4, ∗8)
B–R
G–Y
B–R
B–R B–R B–R B–R
L L
(∗4) (∗4)
96
HIACE (EM04Z2E)
(BAT) ∗ 1 : Australia, Chile, China, Ecuador, Hong Kong, New Zealand, Thailand
10A Nicaragua, Niger, Panama, Peru, South Africa, Vietnam
ETCS ∗ 4 : ∗1, ∗2 ∗3
∗ 5 : Costa Rica, Egypt, El Salvador, G. C. C. , Guatemala, Honduras, Malaysia, Nicaragua,
Panama, Peru, Russia, South Africa, Ukraine, Vietnam
2 ∗ 6 : Before Oct. 2006 Production
∗ 7 : Egypt, G. C. C. , Russian
∗ 8 : ∗5 ∗6, ∗2 ∗7
2
∗ 9 : Except ∗4, Except ∗8
∗10 : Shielded
Y–B
B1
Accelerator Position Sensor
Oil Control Valve

Camshaft Timing
D19
VCP2 EPA2 VPA2 VCPA EPA VPA
1 2 3 4 5 6 2
W–R
W–L
G–B
Y–B
B–Y
R–L
W
B
7 A 27 A 21 A 19 A 26 A 20 A 18 A 13 D 12 D
+BM VCP2 EPA2 VPA2 VCPA EPA VPA OC1+ OC1–
B7(B), B9(A), D1(D), D3(C)
Engine ECU
RTHW THW E2 VTA2 VTA1 M+ M– GE01 VC VAF
31 C 32 D 28 D 19 D 20 D 5 D 4 D 8 D 18 D 25 D
L–R
(∗9)
B
(∗10)
R–W
Y–R
L–B
17 DB1
G
L
L–R
D44 4 6 2 1 2 3
Water Temp. Sensor
Water Temp. Sensor
2 2 Junction VTA2 VTA M+ M–

L–B
(∗9)
VC VAF
2 Connector
(Engine Coolant)
9 11
(Radiator)
8 3
D32
E2 VC E2
B29
Y–R
1 1 3 D29 5 10 D44 1 D31

Throttle Body Junction Variable
Y–R
Assembly Connector Resistor

Y–R
Y–R
(∗9)
16 DB1
Y–R
Y–R Y–R Y–R Y–R Y–R

(∗4, ∗8)
B–R B–R
L L
(∗4) (∗4)
97
HIACE (EM04Z2E)
(BAT) ∗ 3 : Algeria, Costa Rica, El Salvador, Guatemala, Honduras, Mexico,
∗ 4 : ∗1, ∗2 ∗3
120A ∗ 5 : Costa Rica, Egypt, El Salvador, G. C. C. , Guatemala, Honduras, Malaysia,
MAIN4 Nicaragua, Panama, Peru, Russia, South Africa, Ukraine, Vietnam
∗ 6 : Before Oct. 2006 Production
∗ 8 : ∗5 ∗6, ∗2 ∗7
∗10 : Shielded
1 1G
B–G
D20 D21 D22 D23

G
1 5G 4 5E (No. 1) (No. 2) (No. 3) (No. 4)
15
Connector
Junction
IGT1 IGF IGT2 IGF IGT3 IGF IGT4 IGF

10A TAIL
B35
Relay
T–LP
16 3 2 3 2 3 2 3 2
W–R
W–R
W–R
W–R
L–W
Y–R
B–Y
R–L
G
9 5S
W–R W–R W–R W–R
R–G
Connector
Junction
D44
G
Combination
W–R
L–W
Y–R
B–Y
R–L
SW
15 A 17 D 16 D 15 D 14 D 23 D
ELS IGT1 IGT2 IGT3 IGT4 IGF1
B7(B), B9(A), D1(D), D3(C)
Engine ECU
HA1A(∗4) A1A+(∗4)
PSW HT1B OX1B HT1A(∗8) OX1A(∗8) A1A– KNK1 EKNK
32 C 2 D 25 D 1 D 21 D 31 D 29 D 30 D
(∗10)
G–W
R
(∗10)(∗4)
(∗10)(∗8)
(∗10)(∗4)
(∗4)
(∗4)
(∗8)
(∗8)
(∗4)
(∗4)
(∗4)
2 Dg1 1 Dg1
Y
1
Oil Pressure SW
Power Steering
W
B
Heated Oxygen Sensor

D16
1 3 1 3 3 4
Air Fuel Ratio Sensor
HT1B OX1B HT1A OX1A A1A+ A1A– 2

Knock Control Sensor
(Bank 1 Sensor 2)
(Bank 1 Sensor 1)
(Bank 1 Sensor 1)
+B E2 E2 +B HA1A +B
(∗10)
(Bank 1)
D35
D34
D33
2 4 4 2 1 2
g1
B–R
Y–R
Y–R
B–R
(∗4)
(∗4)
(∗8)
(∗8)
(∗4)
1
L
Y–R
(∗4, ∗8)
(∗10)
(∗4)
10
B–R
DB1 2 5
L
(∗4)
6 7 D43
(∗10)(∗8) Junction
Connector
(∗10)
(∗4)
98
HIACE (EM04Z2E)
(ST) (BAT) (IG)
L–R
7. 5A 30A 10A
ST DEF GAUGE
2 2
2
5E
4
Assembly Center
B–W
Airbag Sensor
DEF
7
Connector
Relay
B4(A)
13
Junction
10 B–W GSW2
DB1
B34
22 A
9 3
ST Relay
B–W B–W
B–W
DB3
Cooling Fan ECU No. 1

(A/T)
L
10A 12 5Q
ELS
4
P–B
B34
Junction L B
R
Connector
(M/T)
15 5E
B–W
16 18
P
11 5M
B–W
Defogger SW
Rear Window
19 N
R
D37
L–R
5 8 5E
7
R 12 DB1
DB3
(A/T) 27 HB1
R
LG–B
B–W
L
L–R
12 A 30 A 3 B 10 A 32 B
STA NSW ELS3 RFC F/PS
B7(B), B9(A), D1(D), D3(C)
Engine ECU
E1 G2 NE– NE+ ME01 E04 EC E03 E01 E02
3 D 26 D 34 D 27 D 3 C 7 C 22 A 4 C 7 D 6 D
B
(∗4, ∗8)
W–B
W–B
W–B
(∗4)
BR
BR
BR
Y
4
12 L
BR
5 D44
Junction
Connector
(∗10)
(∗10)
Y
Y
L
Junction Connector
2 1 13
1 NE– NE
Position Sensor
Position Sensor
B36
Crankshaft
Camshaft
12
(∗10)
(∗10)
B–R
BR
(∗4, ∗8)
D10
D17
G–
W–B
W–B
W–B
(∗4)
BR
BR
BR
2 3
BR BR
11 8 9 10
1 W–B
D43
Junction Connector
D2 D1 B2 D2
99
HIACE (EM04Z2E)
(BAT)
L–R
H18 7. 5A
OBD
A/C Amplifier
CANH CANL
10 11 5 5S
W
W
R
L
L–R
B
1 A 2 A 1 C 2 C
1 B 2 B H3(A), H4(B), H5(C)

Junction Connector
W
B
B
11 HB4 22 HB4
W
B
33 B 34 B 14 6 16
CANH CANL CANL CANH BAT
B7(B), B9(A), D1(D), D3(C) H23
Engine ECU DLC3
ALT SPD THWO W TACH TC TC TAC SG CG
10 D 8 B 14 B 30 B 1 B 17 B 13 9 5 4
W
6 DB3
W–B
G–R
B–Y
P–B
B–Y
P–L
BR
Y
P
W
4 5H 15 6C
9
Connector
12 HB4 2 6F
Junction
57 HB1 18 HB1
B35
8
BR
7 5E 16 6C 14 6C
B–Y
W
1 6F
B–Y
2 DB3
W–B
2 DB5
W
3 B
M G–R
Alternator
Y
D6(B)
P–L
BR
BR
W–B
B–Y
H2
100
HIACE (EM04Z2E)
(IG) (BAT) ∗11 : Before Oct. 2006 Production, RHD From Oct. 2006 Production
until Apr. 2009 Production
∗12 : LHD From Oct. 2006 Production, RHD From Apr. 2009 Production
10A 10A
MET IGN DOME
1 5M 2
R
L–R
B–R
18 5E
8 5S
R
H20
6 5 Combination Meter
IG+ B
Speedometer
Tachometer
Temp.
Engine
Check
EGW S +S S E1 SI E3
32 17 9 14 7 15 29
B–Y
P–L
BR
G–R
14 5D 58 HB1 22 HB1
(∗11)
W–B
21 HB1
L–R
BR
P
24 5E
G–R
3 DB4 7 DB4 5 DB4

P–L
1 HH1
4
Connector
L–R
BR
Junction
P
B35
G–R 3 2
7
SI E
Y
(∗11)
(∗12)
W–B
W–B
P–L
P–L
IG+
1 D38
Speed Sensor
L–R
B–Y
H2
101
HIACE (EM04Z2E)
: Parts Location
48 (LHD) D10 52 (*4) 44 (*1)
A3 D33
58 (RHD) 44 (*1) 52 (*4)
D16
48 (LHD) 52 (*4) 44 (*1)
B1 D34
58 (RHD) 44 (*1) 52 (*4)
D17
48 (LHD) 52 (*4) 44 (*1)
B2 D35
58 (RHD) 44 (*1) 52 (*4)
D19
48 (LHD) 52 (*4) 44 (*1)
B4 A D37
58 (RHD) 44 (*1) 52 (*4)
D20
44 (*1) 52 (*4) 44 (*1)
B7 B D38
52 (*4) 44 (*1) 52 (*4)
D21
44 (*1) 52 (*4) 44 (*1)
B9 A D43
52 (*4) 44 (*1) 52 (*4)
D22
44 (*1) 52 (*4) 44 (*1)
B12 B D44
52 (*4) 44 (*1) 52 (*4)
D23
44 (*1) 52 (*4) 42, 49 (LHD)
B14 A H3 A
52 (*4) 44 (*1) 42, 59 (RHD)
D24
44 (*1) 52 (*4) 42, 49 (LHD)
B17 H4 B
52 (*4) 44 (*1) 42, 59 (RHD)
D25
44 (*1) 52 (*4) 42, 49 (LHD)
B29 H5 C
52 (*4) 44 (*1) 42, 59 (RHD)
D26
48 (LHD) 52 (*4) 49 (LHD)
B34 H18
58 (RHD) 44 (*1) 59 (RHD)
D27
44 (*1) 52 (*4) 49 (LHD)
B35 H20
52 (*4) 44 (*1) 59 (RHD)
D28
44 (*1) 52 (*4) 49 (LHD)
B36 H23
52 (*4) 44 (*1) 59 (RHD)
D29
44 (*1) 52 (*4) 49 (LHD)
D1 D H25
52 (*4) 44 (*1) 59 (RHD)
D30
44 (*1) 52 (*4) 44 (*1)
D3 C g1
52 (*4) 44 (*1) 52 (*4)
D31
44 (*1) 52 (*4) 51 (LHD)
D6 B h2
52 (*4) 44 (*1) 61 (RHD)
D32
D10 44 (*1) 52 (*4)
: Relay Blocks

1E
24
1G
Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
1I
25
1J
5C
30 Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5D
5E
5G
5H
30
5J
5M Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5Q 31
5S
102
HIACE (EM04Z2E)
38 (LHD) Instrument Panel Wire and Center J/B (Instrument Panel Reinforcement LH)
6C
38 (RHD) Instrument Panel Wire and Center J/B (Instrument Panel Reinforcement RH)
6F

66 (LHD)
AB1 Cowl to Head Lamp Wire and Engine Room Main Wire (Left Side of the Instrument Panel J/B)
74 (RHD)
62 (*1)
BD1 Engine Room Main Wire and Engine Wire (Front Floor Panel Right)
70 (*4)
68 (LHD)
BP1 Engine Room Main Wire and Frame Wire (Under the Floor Panel)
76 (RHD)
62 (*1)
DB1
70 (*4)
62 (*1)
DB3
70 (*4)
62 (*1)
DB4
70 (*4)
62 (*1)
DB5
70 (*4)
62 (*1)
Dg1 Engine Wire and Sensor Wire (Left Side of Cylinder Block)
70 (*4)
66 (LHD)
HB1
74 (RHD)
66 (LHD)
HB2
74 (RHD)
66 (LHD)
HB4 Instrument Panel Wire and Engine Room Main Wire (Under the Instrument Panel J/B)
74 (RHD)
66 (LHD) Instrument Panel Wire and Instrument Panel Wire (Near the Steering Column)
HH1
74 (RHD) Instrument Panel Wire and Instrument Panel Wire (Instrument Panel Reinforcement RH)
68 (LHD)
Ph1 Frame Wire and Fuel Tank Wire (Near the Fuel Tank)
76 (RHD)
: Ground Points
62 (*1)
B2 Front Floor Panel Right
70 (*4)
62 (*1)
D1
70 (*4)
Engine Block
62 (*1)
D2
70 (*4)
66 (LHD)
74 (RHD)
103
HIACE (EM04Z2E)
Engine Control (1KD-FTV, 2KD-FTV)
(BAT) (BAT) BR
80A 25A B–R

GLOW EFI
2 1
1J
1 1E
MAIN
Relay
B–W
3 1J 2 1J 4 1J
EDU Relay
B–R
W–B
G–Y
B–R
Connector
Junction
8 1J 7 1J
B37
2
R–L
B
B–R
G
B–W
15 A 2 B
GREL BATT
B7(B), B9(A), D1(D), D3(C)
1 1 Engine ECU
IREL +B MREL
5 2 10 A 1 A 8 A
GLOW
Relay
G–Y
B–R
B–R
R–L
3 1
1 1
B–R
W–B
B
14 DB1
W–B
B
1 W–B
W–B
D53
Glow Plug
BR
B2
104
HIACE (EM04Z2E)
∗ 1 : 1KD–FTV
BR ∗ 2 : 2KD–FTV
∗ 3 : 2KD–FTV Wide Body
B–R B–R B–R
L–B
Y–R Y–R Y–R

B–R
B–R
B–R
(∗2)
(∗1)
(∗2)
Y–R
8
Connector
4 DB3 5 DB1 8 DB3
Junction
D44
B–R
B–R
B–R
Y–R
Y–R
L–B
(∗2)
(∗1)
(∗2)
BR
3 2
(∗1, ∗3)
B–R
Y–R
Y–R
(∗1)
B–R
(∗1)
1 1
Inlet Air Temp. Sensor
Fuel Temp. Sensor

2 A 3 A 1 B 2 B
B(∗1) RSC(∗1) VC E(∗1)
B–R
B–R
(∗1)
(∗1)
(Intake Manifold)
+B(∗2) E1(∗2) E2(∗2)
VTA(∗1)
1 2 1 DUTY VAF(∗2)
VSV (EGR Cut)
D46
Control Valve
1 A 3 B D48(A), D50(B)
VRV (EGR)
D49
Throttle Body 2 2
Assembly
Swirl
D55
D67
D68
(∗1, ∗3)
Y–R
R–L
2 1 2
R
B–W
W–L
R–L
(∗1)
(∗1)
W
9 C 15 D 18 C 4 C 29 C 20 D 28 D 29 D
EGR SCV EGRC LUSL VLU THIA E2 THF
B7(B), B9(A), D1(D), D3(C)
Engine ECU
PRD INJF #1 #2 #3 #4
32 D 25 D 24 D 23 D 22 D 21 D
G–R
G–Y
Y–B
B–Y
(∗1)
V
2 A (∗1) 1 A (∗1)
1 B (∗2) 2 B (∗2)
Fuel Injector
Fuel Injector
D24(A), (B)
D27(A), (B)
(No. 1)
(No. 4)
1 A (∗1) 2 A (∗1)
2 B (∗2) 1 B (∗2)
G
G
R
B
2 BD1 17 BD1 15 BD1 6 BD1 16 BD1 7 BD1 13 BD1 14 BD1 10 BD1 3 BD1
R
2
Connector
Junction
3
B38
G–R
G–Y
V–R
Y–B
B–Y
(∗1)
G
B
1
R
6 C 5 E 1 D 6 E 2 E 1 E 3 E 5 C 1 C 4 C (∗1)
8 A 7 B 6 B 3 B 2 B 5 B 4 A 5 A 3 A (∗2)
+B PRD INJF # 10 # 20 # 30 # 40 INJ1 COM1 INJ4
B13(A), B15(B), B40(C), B41(D), B42(E)

Injector Driver (EDU)
BR BR
105
HIACE (EM04Z2E)
∗ 1 : 1KD–FTV
∗ 2 : 2KD–FTV
B–R B–R(∗1)
L–B L–B L–B
Y–R Y–R Y–R Y–R Y–R
B–R
Y–R
Y–R
(∗1)
3 AB1 9 DB1
Y–R 16 DB1
B–R
(∗1)
(∗1)
Y–R
A27
Y–R
Water Temp. Sensor (Engine Coolant)
Air Flow
Meter 1 5
Y–R
L–B
Y–R
+B E2
20 AB1
E2G VG THA
Water Temp. Sensor

1 1 1 3
2 3 4
Turbo Pressure
Y–R
E VC
(∗1)
(∗2)
R
B–L
(∗1)
(∗1)
B
Sensor
(Radiator)
D51
1 PIM
D32
B29
11 AB1 10 AB1 19 AB1 2
(Air Cleaner)
2 2
B–L
(∗1)
(∗1)
(∗2)
R
R
B
R–W
L–R
A2
P
11 DB1 10 DB1 8 DB1 2
B–L
(∗1)
(∗1)
R
B
19 D 32 C 24 C 31 D 20 A 28 C
THW EVG VG THA RTHW PIM
B7(B), B9(A), D1(D), D3(C)
Engine ECU
2 A (∗1) 1 A (∗1)
1 B (∗2) 2 B (∗2) 1
Discharge Valve
Fuel Injector
Fuel Injector
D25(A), (B)
D26(A), (B)
Pressure
(No. 2)
(No. 3)
D64
BR
1 A (∗1) 2 A (∗1) 2
2 B (∗2) 1 B (∗2)
W–R
(∗1)
(∗1)
BR
W
Y
Y
L
5 BD1 12 BD1 11 BD1 4 BD1 8 BD1 18 BD1 9 BD1

Y
3
Connector
Junction
2
B39
L
W–R
(∗1)
(∗1)
1
BR
W
L
Y
4 D 2 C 2 D 3 C 3 D 4 E (∗1)
2 A 6 A 1 A 1 B (∗2)
INJ2 COM2 INJ3 COM3 PRV GND
B13(A), B15(B), B40(C), B41(D), B42(E)

BR BR
106
HIACE (EM04Z2E)
B–R(∗1)
B–R(∗1)
L–B L–B L–B
Y–R Y–R
O3(A)
Transmission
Control ECU
CAN+ CAN–
21 A 20 A
Y–R
Y–R
L–R
L–B
L–B
W
L
4 A 6 A (∗1)
2 1 1 B 3 B (∗2)
Position Sensor
D45(B), D69(A)
Fuel Pressure
11
Connector
E2 VC E2 VC
Junction
EGR Valve
9 DO1 19 DO1
D44
Sensor
D52
EGLS PR E2S VCS PR2

9
3 5 A 3 A 1 A 2 A (∗1)
W
L
2 B (∗2)
1 DB2 6 DB2
G–R
G–B
L–B
(∗1)
(∗1)
(∗1)
G
P
W
L
33 C 26 D 1 C 2 C 33 D 18 D 22 B 21 B
EGLS PCR1 E2S VCS PCR2 VC CAN+ CAN–
B7(B), B9(A), D1(D), D3(C)
Engine ECU
G+(∗1)
E1 G1(∗2) G– NE+ NE– PCV+ PCV– E02 E01 EC
7 C 23 C 31 C 27 D 34 D 2 D 1 D 6 D 7 D 6 B
(Shielded)
W–B
Y–R
BR
BR
P
BR
G
R
(Shielded)
G(∗1)
R(∗1)
Y(∗2)
L(∗2)
BR
1 1
Position Sensor
Control Valve
Camshaft
Suction
D10
D47
1 2
Position Sensor
2 NE NE– 2
Crankshaft
13
Connector
Junction
D17
G–
B36
3
12
BR
W–B
(Shielded)
(Shielded)
BR
BR
2 11 3 5
W–B
4 1 D43
BR
BR
Junction Connector
BR BR
BR
D3 B2
107
HIACE (EM04Z2E)
B–R(∗1) B–R(∗1)
(IG) (BAT) (ST)

∗ 1 : 1KD–FTV
∗ 2 : 2KD–FTV
15A 10A 7. 5A
IGN STOP ST
4
9 5E 21 5E 3 5J 4 5J 6 5E
B–W
7
Connector
R–W
R–W
G–B
B–R
B–R
13
Junction
10 B–W
DB1
B34
9 3
ST Relay
17 HB4 19 HB4 B–W B–W
B–W
DB3
(A/T)
R–W
G–B
19 Connector 4
B34
Junction
Junction L B
R
3 2
B35
Connector
(M/T)
B–W
Stop Lamp SW
16 18
B–W
20 P
19 N
D37
B2
4 1 5 12 DB1
7
R
R–W
R–W DB3
(A/T)
B–R
R–L
B–W
R
9 A 14 B 15 B 7 A 6 A
IGSW ST1– STP STA NSW
B7(B), B9(A), D1(D), D3(C)
Engine ECU
ALT VCP2 EPA2 VPA2 VCPA EPA VPA RFC RFC2 FAN
8 D 27 A 29 A 23 A 26 A 28 A 22 A 12 D 11 D 13 D
W
LG–B
W–L
P–L
W–R
W–L
R–L
W
B
6 DB3
3 DB2 8 DB2 17 DB1
1 2 3 4 5 6
LG–B
W
W–L
P–L

9
Connector
Junction
B35
8
FAN3 Relay
W
2 DB3
B1
W
3 B
M
Alternator
D6(B)
108
HIACE (EM04Z2E)
B–R(∗1) D65(A), D66(B)
Turbocharger Variable Nozzle Motor Assembly
VTA2 VTA1 E2S VCS VNE2 VNVC M– M+

4 B 1 B 5 B 6 B 2 B 3 B 1 A 2 A
(Shielded)
R–W
Y–L
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
G
G
R
R
Y
L
11 DB7 12 DB7 2 DB7 3 DB7 7 DB7 8 DB7 6 DB7 5 DB7 4 DB7
(Shielded)
R–W
B–R
Y–L
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
G
G
R
R
Y
L
3 10 9 11 6 8 1 5 12
+B VTA2 VTA1 E2S VCS VNE2 VNVC M– M+
VNTO VNTI GND

7 2 B43 4
Turbo Motor Driver
Y–G
Y–B
(∗1)
(∗1)
(∗1)
(∗1)
BR
BR
14 DB7 15 DB7 9 DB7 13 DB7
Y–G
Y–B
(∗1)
(∗1)
(∗1)
(∗1)
BR
BR
10 D 17 D
VNTO VNTI 13 7
D43
B7(B), B9(A), D1(D), D3(C) Junction
Engine ECU Connector
1 10
SPD THWO GIND W TACH WFSE TC SIL CANL CANH
17 B 2 A 14 A 12 A 4 A 19 A 11 A 18 A 23 B 24 B
BR
BR
B–W
G–R
B–Y
L–R
P–L
(∗2)
W
Y
57 HB1 18 HB1 7 HB4 22 HB4 11 HB4

B–Y
L–R
(∗2)
W
Y
L–R(∗2)
B–Y
G–R
B–W
P–L
BR
D3
109
HIACE (EM04Z2E)
H18
A/C Amplifier
(BAT)
CANH CANL 7. 5A
OBD
10 11
W
W
R
L
1 A 2 A 1 C 2 C
5 5S
B
1 B 2 B H3(A), H4(B), H5(C)
Junction Connector
W
R
B
B
14 6 16
CANL CANH BAT
H23
DLC3
SIL TC WFSE SG TAC CG
7 13 15 5 9 4
W–B
P–B
B–Y
L–R
(∗2)
W
BR
3 5S 4 5H
12 HB4 15 6C 2 6F
3 5E 7 5E
BR
B 16 6C 14 6C 1 6F
W
W
9 DB2
W–B
B–Y
B–Y
W
BR
L–R(∗2)
B–Y
G–R G–R
B–W B–W
Y Y
P–L P–L
BR B–Y
H2
110
HIACE (EM04Z2E)
∗ 2 : 2KD–FTV
(IG) (BAT) ∗ 5 : Before Oct. 2006 Production, RHD From Oct. 2006 (IG)
Production until Apr. 2009 Production
∗ 6 : LHD From Oct. 2006 Production,
10A 10A RHD From Apr. 2009 Production 10A
MET IGN DOME GAUGE
1 5M 2 2 5E
R
L–R
18 5E
B–R
8 5S
R
H20
IG+ B
Speedometer
Tachometer
Temp.
Engine
Check
Glow
EGW L S +S S E1 SI E3
32 25 17 9 14 7 15 29
B–Y
P–L
BR
B–W
G–R
14 5D 58 HB1 22 HB1
W–B
(∗5)
21 HB1 60 HB1
L–R
BR
P
24 5E
B–W
G–R
3 DB4 7 DB4 5 DB4

P–L
1 HH1
4
Connector
L–R
BR
Junction
P
B35
3 2
7
SI E
W–B
W–B
P–L
(∗5)
(∗6)
G–R IG+
1 D38
B–W Speed Sensor
L–R
P–L
B–Y
H2
111
HIACE (EM04Z2E)
: Parts Location
48 (LHD) 45 (*2) D47 55 (*5)
A2 D3 C
58 (RHD) 54 (*5) 45 (*2)
D48 A
A27 58 (RHD) 45 (*2) 55 (*5)
D6 B
48 (LHD) 54 (*5) 45 (*2)
B1 D49
58 (RHD) 45 (*2) 55 (*5)
D10
48 (LHD) 54 (*5) 45 (*2)
B2 D50 B
58 (RHD) 45 (*2) 55 (*5)
D17
45 (*2) 54 (*5) 45 (*2)
B7 B D51
54 (*5) A 54 (*5) 55 (*5)
45 (*2) D24 45 (*2) 45 (*2)
B9 A B D52
54 (*5) 54 (*5) 55 (*5)
45 (*2) A 54 (*5) 45 (*2)
B13 A D53
54 (*5) D25 45 (*2) 55 (*5)
B
45 (*2) 54 (*5) 45 (*2)
B15 B D55
54 (*5) A 54 (*5) 55 (*5)
45 (*2) D26 45 (*2) D64 55 (*5)
B29 B
54 (*5) 54 (*5) D65 A 55 (*5)
48 (LHD) A 54 (*5) D66 B 55 (*5)
B34
58 (RHD) D27 45 (*2) D67 55 (*5)
B
45 (*2) 54 (*5) D68 55 (*5)
B35
54 (*5) 45 (*2) D69 A 55 (*5)
D32
45 (*2) 55 (*5) 42, 49 (LHD)
B36 H3 A
54 (*5) 45 (*2) 42, 59 (RHD)
D37
45 (*2) 55 (*5) 42, 49 (LHD)
B37 H4 B
54 (*5) 45 (*2) 42, 59 (RHD)
D38
45 (*2) 55 (*5) 42, 49 (LHD)
B38 H5 C
54 (*5) 45 (*2) 42, 59 (RHD)
D43
45 (*2) 55 (*5) 49 (LHD)
B39 H18
54 (*5) 45 (*2) 59 (RHD)
D44
B40 C 54 (*5) 55 (*5) 49 (LHD)
H20
B41 D 54 (*5) 45 (*2) 59 (RHD)
D45 B
B42 E 54 (*5) 55 (*5) 49 (LHD)
H23
B43 58 (RHD) 45 (*2) 59 (RHD)
D46
45 (*2) 55 (*5) 48 (LHD)
D1 D O3 A
54 (*5) D47 45 (*2) 58 (RHD)
: Relay Blocks
1 23 (*8) Engine Room R/B No.1 (Engine Compartment Front)

1E 24
1J 25
5D 30 Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5H
30
5J
Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5M
31
5S
6C
112
HIACE (EM04Z2E)
6F

66 (LHD)
74 (RHD)
63 (*2)
71 (*5)
63 (*2)
DB1
71 (*5)
63 (*2)
DB2
71 (*5)
63 (*2)
DB3
71 (*5)
63 (*2)
DB4
71 (*5)
DB7 71 (*5) Engine Wire and Engine Room Main Wire (Front Floor Panel Right)
63 (*2)
DO1 Engine Wire and Floor Wire (Front Floor Panel Right)
71 (*5)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
HH1
: Ground Points
63 (*2)
71 (*5)
63 (*2)
D3 Engine Block
71 (*5)
66 (LHD)
74 (RHD)
113
HIACE (EM04Z2E)
Engine Control (5L-E)
(BAT) (BAT) (IG) (BAT)
80A 25A 15A 10A

GLOW EFI IGN STOP
1 1E
9 5E 21 5E 3 5J 4 5J 6 5E
MAIN
Relay
B–W
R–W
G–B
B–R
B–R
R–W
3 1J 2 1J 4 1J 1 1J 17 HB4 19 HB4
R–W
W–B
G–Y
G–B
B–R 19
Connector
Junction
3 2
B35
Stop Lamp SW
20
B2
4 1
R–W
B–W
B–R
B–R
R–L
G
R–W
1 1
2 E 1 E 14 E 11 F 19 E
SREL BATT IGSW ST1– STP
5 2
B8(F), B10(E), D2(H), D4(G)
Engine ECU
GLOW
Relay
+B TCV LU–B LU+B LU–A LU+A MREL
3 1 12 E 11 H 7 H 8 H 9 H 10 H 3 E
1 1
B–W
G–Y
B–R
W
G
B
W–B
B
Timer Control Valve
2 1 3 4 6
14 DB1 LU–B LU+B LU–A LU+A
D61
+B1 +B2
W–B
1 2 5 D58
B
Throttle Body
Assembly
B–R
B–R
B–R
1 W–B
5 DB1 3 DB1 4 DB1

B–R
B–R
B–R
B–R
W–B
D54
Glow Plug
B2
114
HIACE (EM04Z2E)
(ST)
7. 5A
ST
L–B
4
Y–R
H19
A/C Amplifier
6 DB1 1 DB1
R
AC1 ACT
Y–R
L–B
8 10

B1
16
Connector
G–W
Accelerator
R–B
Junction
Position Sensor 1 2
FAN3 Relay
B34
VCP2 EPA2
19
29 HB1 51 HB1
VPA2 VCPA EPA VPA
3 4 5 6
LG–B
G–W
W–L
R–B
W–L
W
R
L
11 E 2 F 8 F 7 E 13 E 12 F 6 F 4 F 5 F
STA AC1 ACT RFC FAN VPA2 VCPA EPA VPA
B8(F), B10(E), D2(H), D4(G)
Engine ECU
PR2 DATA CLK NE+ NE– TDC+ TDC– E1 THOP E01 E02 ALT
8 G 6 G 14 G 19 H 18 H 17 H 16 H 14 H 15 G 13 H 26 H 22 E
Y–G
W
(Shielded)
(Shielded)
(Shielded)
11 DB1 13 DB1
BR
BR
BR
G
R
Y
Y
L
W
Y–G
1 4 2 1 2
DATA CLK 3 B
Position Sensor
Position SW
Engine Speed
17 AB1 M
Crankshaft
Throttle
Alternator
D63
E1
Sensor
D6(B)
D18
D62
Y–G
D60 2 1 2 1
Injection
Pump
Assembly
(Shielded)
(Shielded)
(Shielded)
2
BR
BR
Pressure SW
BR
A5
2 6 4 11 5
3
3 10 BR
D43 1
BR
BR
Junction Connector
W–B
BR
A1 D4
115
HIACE (EM04Z2E)
∗ 1 : Before Oct. 2006 Production, RHD From Oct. 2006 Production

∗ 2 : LHD From Oct. 2006 Production, RHD From Apr. 2009 Production
L–B
Y–R Y–R Y–R Y–R Y–R Y–R
16 DB1
Y–R
Y–R
Y–R
Y–R
Y–R
Y–R
Water Temp. Sensor
Manifold Absolute
1 1 2 1
Pressure Sensor
Fuel Temp. Sensor
Water Temp. Sensor

1
(Engine Coolant)
(Air Cleaner)
R–L
D57
PIM VC
(Radiator)
D46
D32
2 DB1 2 3
A2
B29
2 2 19 AB1 1
Y–R
L–B
2
Y–R
R–L
L–R
20 AB1 L–B
7 DB1 17 DB1
L–B
P
R–W
Y–R
R–L
L–R
R
5 G 4 G 9 G 3 G 2 G 1 G 12 G
THF THW E2 THA PIM VC RTHW
B8(F), B10(E), D2(H), D4(G)
Engine ECU
SPV+ SPV– HSW TACH SPD THWO GIND W SIL TC

12 H 25 H 20 E 7 F 9 E 8 E 1 F 5 E 15 E 4 E
B–W
G–R
L–W
B–Y
P–L
W
Y
P
W–B
B–L
B
14 HB2 18 HB1
I12(A), I13(B)
7 B
Connector
57 HB1
L–W
Junction
B–Y
Spill Control Valve
2 7 A
6 IH2
16 6C
W–B
L–W
D59
P
1 17 IH3 (LHD)
17 IH4 (RHD) 3 W
15 6C 14 6C
Idle–Up SW
G–R
W–B
B–Y
B–Y
B–W
I6
4
13 Y
Connector
Junction
W–B
H41
P–L
1
BR B–Y
W–B
B–Y
BR
H1
116
HIACE (EM04Z2E)
(BAT) (IG) (BAT) (IG)
7. 5A 10A 10A 10A

OBD MET IGN DOME GAUGE
5 5S 1 5M 2 2 5E
L–R
B 18 5E
B–R
8 5S
R
H20
IG+ B
Speedometer
Tachometer
Temp.
B
16
Engine
Check
Glow
BAT
H23
DLC3
TC SIL TAC SG CG
13 7 9 5 4
EGW L S +S S E1 SI E3
W–B
P–B
B–Y
BR
W
32 25 17 9 14 7 15 29
B–Y
P–L
4 5H 3 5S 12 HB4 2 6F BR
B–W
G–R
14 5D 58 HB1 22 HB1
W–B
(∗1)
BR
21 HB1 60 HB1 L–R

BR
7 5E 3 5E 1 6F
P
24 5E
B–W
G–R
9 DB1 1 HH1 3 DB4 7 DB4 5 DB4

W–B
P
P–L
W 4
Connector
L–R
BR
BR
Junction
G–R
B35
3 2
7
B–W SI E
W–B
W–B
P–L
(∗2)
(∗1)
P–L IG+
1 D38
B–Y Speed Sensor
L–R
B–Y
BR
W–B
H2 H2
117
HIACE (EM04Z2E)
: Parts Location
48 (LHD) 46 (*3) 46 (*3)
A2 D6 B D61
58 (RHD) 56 (*6) 56 (*6)
48 (LHD) 46 (*3) 46 (*3)
A5 D18 D62
58 (RHD) 56 (*6) 56 (*6)
48 (LHD) 46 (*3) 46 (*3)
B1 D32 D63
58 (RHD) 56 (*6) 56 (*6)
48 (LHD) 46 (*3) 49 (LHD)
B2 D38 H19
58 (RHD) 56 (*6) 59 (RHD)
46 (*3) 46 (*3) 49 (LHD)
B8 F D43 H20
56 (*6) 56 (*6) 59 (RHD)
46 (*3) 46 (*3) 49 (LHD)
B10 E D46 H23
56 (*6) 56 (*6) 59 (RHD)
46 (*3) 46 (*3) 49 (LHD)
B29 D54 H41
56 (*6) 56 (*6) 59 (RHD)
48 (LHD) 46 (*3) 49 (LHD)
B34 D57 I6
58 (RHD) 56 (*6) 57 (RHD)
46 (*3) 46 (*3) 49 (LHD)
B35 D58 I12 A
56 (*6) 56 (*6) 57 (RHD)
46 (*3) 46 (*3) 49 (LHD)
D2 H D59 I13 B
56 (*6) 56 (*6) 57 (RHD)
46 (*3) 46 (*3)
D4 G D60
56 (*6) 56 (*6)
: Relay Blocks

1E 24
1J 25
5H
30
5J
5M
31
5S
6C
6F

66 (LHD)
74 (RHD)
64 (*3)
DB1
72 (*6)
64 (*3)
DB4
72 (*6)
66 (LHD)
74 (RHD)
118
HIACE (EM04Z2E)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
HH1
66 (LHD)
IH2 Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Reinforcement LH)
74 (RHD)
IH3 66 (LHD)
Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Reinforcement RH)
IH4 74 (RHD)
: Ground Points
66 (LHD)
A1 Dash Panel Right
74 (RHD)
64 (*3)
72 (*6)
64 (*3)
D4 Engine Block
72 (*6)
66 (LHD)
H1
74 (RHD)
Instrument Panel Reinforcement
66 (LHD)
H2
74 (RHD)
119
HIACE (EM04Z2E)
Engine Immobiliser System (2TR-FE)
(IG)
(BAT)
∗ 1 : RHD From Sep. 2007 Production
15A ∗ 2 : Except ∗1
IGN 10A ∗ 3 : Before Oct. 2006 Production, RHD From Oct, 2006
ECU–B Production until Apr. 2009 Production
RHD From Apr. 2009 Production
2
1 5D
2
W–R
B–R
B–R
H43
(∗2)
(∗1)
Transponder Key Amplifier
11 6C VC5 CODE TXCT AGND

1
Connector
17 5E 1 4 5 7
Junction
H46
3
13 6C
2 5S
GR
V
Y
L
B–R
B–R
(∗2)
(∗1)
W–R
2 1 14 15 4 5
IG +B VC5 CODE TXCT AGND
H44
Transponder Key ECU
EFII EFIO GND D IND KSW CTY

12 13 16 9 8 3 7
Y
W–R
B–W
R–G
W
4 6B
W–B
W–B
(∗1)
(∗2)
52 HB1 15 HB1
12 6C 2 6B 3 6B 18 6D
2
Connector
Junction
(M/T)
W–R
(A/T)
B–W
Y–B
Y
H46
35 13 6D
Combination Meter
1
11 6C 19 6C 2 2
LP
15 B 16 B
Security
Warning SW
Warning SW
R–G
IMO IMI
Unlock
Unlock
W–B
W–B
(∗1)
(∗2)
H20
H26
H27
E1
17 6C 7 1 1 7 5D
B7(B)
(M/T)
Engine ECU
(A/T)
W–B
W–B
27 5E
W–B
(∗3)
W
1 5C 16 6F 17 6F
(RHD)
7
(LHD)
R–G
R–L
SIL
12 5E 1 HH1 10 6F
W–B
(∗4)
Door Courtesy SW
Door Courtesy SW
1 1
W–B
(Front RH)
(Front LH)
H23
DLC3 9 6F
W–B
B22
B26
W–B
(∗3)
1 6F
W–B
B3 H2 H2
120
HIACE (EM04Z2E)
: Parts Location
44 (*1) H20 59 (RHD) 49 (LHD)
B7 B H43
52 (*4) 49 (LHD) 59 (RHD)
H23
50 (LHD) 59 (RHD) 49 (LHD)
B22 H44
60 (RHD) 49 (LHD) 59 (RHD)
H26
50 (LHD) 59 (RHD) 49 (LHD)
B26 H46
60 (RHD) 49 (LHD) 59 (RHD)
H27
H20 49 (LHD) 59 (RHD)
: Relay Blocks

5C
5D
5S 31 Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
6B
6C
6D
6F

66 (LHD)
74 (RHD)
HH1
: Ground Points
62 (*1)
70 (*4)
66 (LHD)
74 (RHD)
121
HIACE (EM04Z2E)
Engine Immobiliser System (1KD-FTV, 2KD-FTV)
(IG) (BAT)

15A 10A ∗ 2 : Except ∗1
IGN ECU–B ∗ 3 : Before Apr. 2009 Production
∗ 4 : From Apr. 2009 Production
1 5D 2
H43
W–R
B–R
B–R
(∗2)
(∗1)
VC5 CODE TXCT AGND

11 6C 17 5E 1 4 5 7
1
Connector
Junction
H46
3
13 6C 2 5S
GR
V
Y
L
B–R
B–R
(∗2)
(∗1)
W–R
2 1 14 15 4 5
H44
Transponder Key ECU
EFII EFIO GND D IND KSW CTY

12 13 16 9 8 3 7
Y
W–R
B–W
R–G
W
4 6B
W–B
W–B
(∗1)
(∗2)
52 HB1 15 HB1
12 6C 2 6B 3 6B 18 6D
2
Connector
Junction
(M/T)
W–R
(A/T)
B–W
Y–B
Y
H46
35 13 6D
Combination Meter
1
11 6C 19 6C 2 2
LP
29 B 30 B
Security
Warning SW
Warning SW
R–G
IMO IMI
Unlock
Unlock
W–B
W–B
(∗1)
(∗2)
H20
H26
H27
E1
17 6C 7 1 1 7 5D
B7(B)
(M/T)
Engine ECU
(A/T)
W–B
W–B
27 5E
W–B
(∗3)
W
1 5C 16 6F 17 6F
7
R–L
SIL
12 5E 1 HH1 10 6F
W–B
(∗4)
Door Courtesy SW
1
W–B
(Front RH)
H23
DLC3 9 6F
W–B
B26
W–B
(∗3)
1 6F
W–B
B3 H2 H2
122
HIACE (EM04Z2E)
: Parts Location
B7 B 54 (*5) H23 59 (RHD) H43 59 (RHD)
B26 60 (RHD) H26 59 (RHD) H44 59 (RHD)
H20 59 (RHD) H27 59 (RHD) H46 59 (RHD)
: Relay Blocks

5C
5D
6B
6C
6D
6F

HB1 74 (RHD) Instrument Panel Wire and Engine Room Main Wire (Near the Steering Column)
HH1 74 (RHD) Instrument Panel Wire and Instrument Panel Wire (Instrument Panel Reinforcement RH)
: Ground Points
H2 74 (RHD) Instrument Panel Reinforcement
123
HIACE (EM04Z2E)
DLC3
(BAT)
7. 5A
OBD
B4(A) B19
∗ 1 : 2TR–FE Airbag Sensor Skid Control ECU
Assembly Center with Actuator
∗ 3 : 5L–E
5 5S
∗ 4 : w/ Engine Immobiliser System
∗ 5 : w/o Engine Immobiliser System TC SIL D/G TC TS
∗ 6 : 2KD–FTV
15 A 16 A 14 16 15 H44
Transponder
B
Key ECU
L–Y
W
P
P–B
W
15 AB1 14 AB1 18 HB4 D
9
(∗2, ∗3)
L–Y
W
P
W
P
(∗4)
W
7 5E 3 5E 13 5E 31 5E 26 5B 25 5B
18 6C 19 6C
(∗2, ∗3)
W
4 5H 3 5S
L–Y
B
W
B7(B), B8(F), B9(A), B10(E)
17 B (∗1) (∗4) 17 6C
P–B
(∗5)
18 A 11 A (∗2)
W
15 E 4 E (∗3) W
SIL TC (∗4)
13 7 12 16
Engine ECU
TC SIL TS BAT
TACH WFSE H23

DLC3
1 B (∗1) 19 A
4 A (∗2) WFSE TAC CANH CANL SG CG
7 F (∗3) 15 9 6 14 5 4
(∗1, ∗2)
(∗1, ∗2)
B–Y
L–R
(∗6)
W
R
W–B
B–Y
L–R
(∗6)
BR
15 6C
18 HB1 7 HB4 12 HB4 2 6F

B–Y
L–R
(∗6)
Connector
16 6C 14 6C
Junction
BR
1 6F
2 DB5 (∗1)
W–B
B–Y
9 DB2 (∗2)
9 DB1 (∗3)
BR
Combination Meter
14
S
10
D43
Junction
H20
Connector
1
W–B
W–B
(∗1)
(∗2)
(∗3)
BR
BR
D2 D3 D4 H2
124
HIACE (EM04Z2E)
: Parts Location
48 (LHD) 44 (*1) 55 (*5)
B4 A D43
58 (RHD) 45 (*2) 56 (*6)
44 (*1) 46 (*3) 49 (LHD)
B7 B B19 H20
52 (*4) 52 (*4) 59 (RHD)
46 (*3) 54 (*5) 49 (LHD)
B8 F H23
56 (*6) 56 (*6) 59 (RHD)
45 (*2) 44 (*1) 49 (LHD)
B9 A H44
54 (*5) 45 (*2) 59 (RHD)
D43
46 (*3) 46 (*3)
B10 E
56 (*6) 52 (*4)

5B 30 Cowl to Head Lamp Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5H 30
5S 31
6C
6F

66 (LHD)
74 (RHD)
64 (*3)
DB1
72 (*6)
63 (*2)
71 (*5)
62 (*1)
DB5
70 (*4)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
: Ground Points
62 (*1)
D2
70 (*4)
63 (*2)
D3 Engine Block
71 (*5)
64 (*3)
D4
72 (*6)
66 (LHD)
74 (RHD)
125
HIACE (EM04Z2E)
Headlight
∗ 1 : Before Oct. 2006 Production, RHD From Oct. 2006 Production (BAT)
RHD From Apr. 2009 Production 40A
HEAD
W–L
W–R
4
W–R
W–R
1 1
4 4 15A 15A
HEAD HEAD
LH RH
1 3
2
2 2
(Headlight)
HEAD
Relay
Diode
H38
4 4
1 3 2 5
HB2
R
L
R–W
R–W
R–B
4 4
7 6E 3 6E 1 6E 8 AB1 9 AB1
R–W
W–L
R
L
Headlamp (RH)
Headlamp (LH)
3 3
4 6E 2 6E
A19
A7
R–W
R–B
1 2 1 2
R–B
R–B
13 A 8 A 17 A (LHD) 18 5H
R–B
R–B
R–L
R–L
14 B 1 B 10 B (RHD)
A EL H T HF HU HL
R–B
OFF
16 5B
Control SW
Tail R–B
Light
Head
AUTO
38
Combination Meter
Low
Dimmer SW
+
High Beam
High
Flash
H20
E1
H28(A), H29(B) 16 A 7 A (LHD) 7
Combination SW 9 B 2 B (RHD)
W–B
W–B
R–L
(∗1)
7 6F
R–L
1 HH1
17 35
R–L R–L
5H 5B
W–B
(∗1)
1 6F
W–B
W–B
(∗2)
H2
126
HIACE (EM04Z2E)
: Parts Location
48 (LHD) 49 (LHD) 49 (LHD)
A7 H20 H38
58 (RHD) 59 (RHD) 59 (RHD)
48 (LHD) H28 A 49 (LHD)
A19
58 (RHD) H29 B 59 (RHD)
: Relay Blocks

5H 30 Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
6E
6F

66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
HH1
: Ground Points
66 (LHD)
74 (RHD)
127
HIACE (EM04Z2E)
Front Fog Light
(BAT) (BAT)
15A 120A
FR FOG MAIN4
4 5M 1 1G
G 17 15 G
B–G
L
B35
Junction
24 HB2 Connector 4 5E 1 5G
G
L
10A TAIL
4 4
Relay
T–LP
3 1
FR FOG
Relay
9 5S
5 2
R–G
4 4
49
G–R G–R 19 20 G–R
HB1
Y
2
H42
H42 Junction
Junction Connector
16 AB1 Connector
1
Y
G–R
R–G
Y
11 A 14 A (LHD)
12 B 15 B (RHD)
Y
BFG LFG T H EL A
OFF
2 CA1 1 HA2
Tail
Y
Light
Control SW
Y 30 Head
FOG AUTO
Front Fog
Combination
Y
Off
Front Fog
Meter
(Front RH)
H20
1 1 E1
(Front LH)
Light SW
Fog Lamp
Fog Lamp
On
7
H28(A), H29(B) 10 A 16 A (LHD)
C2
C4
2 2 Combination SW 16 B 9 B (RHD)
W–B
W–B
W–B
W–B
(∗1)
W–B
6 6F 7 6F
1 HH1
W–B
W–B
(∗2)
5 CA1 1 6F
W–B
(∗1)
W–B
W–B

A1 H2 ∗ 2 : LHD From Oct. 2006 Production, RHD From Apr. 2009 Production
128
HIACE (EM04Z2E)
: Parts Location
44 (*1) 48 (LHD) H28 A 49 (LHD)
C2
45 (*2) 58 (RHD) H29 B 59 (RHD)
46 (*3) 48 (LHD) 49 (LHD)
B35 C4 H42
52 (*4) 58 (RHD) 59 (RHD)
54 (*5) 49 (LHD)
H20
56 (*6) 59 (RHD)
: Relay Blocks

1G 24 Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
5E
5G
5M
5S
6F

66 (LHD)
74 (RHD)
66 (LHD)
CA1 Engine Room No.4 Wire and Cowl to Head Lamp Wire (Dash Panel Left)
74 (RHD)
66 (LHD)
HA2 Instrument Panel Wire and Cowl to Head Lamp Wire (Under the Instrument Panel J/B)
74 (RHD)
66 (LHD)
HB1
74 (RHD)
66 (LHD)
HB2
74 (RHD)
HH1
: Ground Points
66 (LHD)
A1 Dash Panel Right
74 (RHD)
66 (LHD)
74 (RHD)
129
HIACE (EM04Z2E)
Rear Fog Light
(BAT) (BAT)
15A 120A
FR FOG MAIN4
4 5M 1 1G
B–G
G
L
15
B35
Junction
24 HB2 Connector 4 5E 1 5G
17
G
L
G–B
10A TAIL
4 4
Relay
T–LP
3 1
FR FOG
Relay
5 2
9 5S
4 4 R–G
49
Y
G–R G–R
HB1
2 19
Connector
(Front LH),
(Front RH)
Junction
Fog Lamp
22 G–B
H42
1 20
G–R
R–G
14 A 11 A
EL A T H BFG LFG
OFF
Tail
Light
Control SW
Head
AUTO
Off
Front Fog
Light SW
On
H28(A) 16 A 13 A 10 A
Combination SW
R–B
R–B
W–B
W–B
7 6F 6 6F
1 6F
W–B
H2
130
HIACE (EM04Z2E)
∗ 1 : Standard Body Standard Roof
(BAT) ∗ 2 : Except ∗1
15A
RR FOG
R–Y
8 5M 4 BT2
R–Y
G
R
T14(A), T15(B)
G–B 16 HB2 1 A (∗2) Junction
1 B (∗1) Connector
G–B
R–Y
7 A (∗2) 6 A (∗2)
3 B (∗1) 2 B (∗1)
9 IH2 20 IH2 10 IH2
V
G–B
R–Y
R
7 4 8 3 TU1
R–Y
FS B L
V
LH E
Rear Combination
Rear Combination
I3 2 2
6 1
Rear Fog Lamp SW
Lamp (RH)
Lamp (LH)
Rear
Rear
R–B
Fog
Fog
W–B
T16
U1
6 6
I12(A), I13(B)
19 IH2 9 B
Connector
Junction
W
R–B
7 A
W–B
3
U2
W
Junction
8 6E Connector
1 2
17 IH3
GR
4 6E
W–B
W–B
R–B
13
Connector
Junction
R–B 3 TU2 (∗2)

H41
9 ZU1 3 TU3 (∗1)

1
W–B
W–B
9 Za1 5 TY2 4 TY2

W–B
W–B
W–B
H1 a1 Y1
131
HIACE (EM04Z2E)
Rear Fog Light
: Parts Location
44 (*1) H42 49 (LHD) T15 B 50 (LHD)
B35 45 (*2) I3 49 (LHD) T16 50 (LHD)
46 (*3) I12 A 49 (LHD) U1 51 (LHD)
H28 A 49 (LHD) I13 B 49 (LHD) U2 51 (LHD)
H41 49 (LHD) T14 A 50 (LHD)
: Relay Blocks

5E
5G
5M
5S
6E
6F

BT2 66 (LHD) Engine Room Main Wire and Roof Wire (Cowl Side Panel LH)
HB1
66 (LHD) Instrument Panel Wire and Engine Room Main Wire (Near the Steering Column)
HB2
IH2 66 (LHD) Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Reinforcement LH)
IH3 66 (LHD) Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Reinforcement RH)
TU1
TU2 68 (LHD) Roof Wire and Roof No.2 Wire (Rear of the Left Side of the Roof Panel)
TU3
TY2 68 (LHD) Roof Wire and Luggage Room No.3 Wire (Left Quarter Panel)
ZU1 68 (LHD) Back Door No.1 Wire and Roof No.2 Wire (Rear of the Right Side of the Roof Panel)
Za1 68 (LHD) Back Door No.1 Wire and Back Door No.2 Wire (Right Side of Back Door)
: Ground Points
H1
66 (LHD) Instrument Panel Reinforcement
H2
Y1 68 (LHD) Left Quarter Panel
a1 68 (LHD) Back Door Right
132
HIACE (EM04Z2E)
Memo
133
HIACE (EM04Z2E)
Turn Signal and Hazard Warning Light
(BAT) (IG) until Apr. 2009 Production
HAZ–HORN ∗ 3 : Standard Body Standard Roof
10A ∗ 4 : Except ∗3
GAUGE
15A
5 1I 1
IG
Flasher Relay
L
+B GND EHW EL ER LL LR
4 7 8 5 6 3 2
13 HB2
L
1 5J 12 5E 7 5M 17 5S 11 5S 12 5S 13 5S 16 5S
L
W–B
W–B
(LHD)
G–W
G–B
G–Y
L–R
L
(RHD)
G–W
1 IH2
1 A 3 A (LHD)
6 B 8 B (RHD)
31 26
(LHD)
G–W
TL TB TR
B B
Turn RH
Turn LH
Signal SW
Combination Meter
LH
Turn
Off
3 3
Hazard Warning
Hazard Warning
RH
H20
E1
Signal SW
Signal SW
H28(A), H29(B) 2 A (LHD) 7

Combination SW 7 B (RHD)
H9
I4
4 4
(LHD)
W–B
I12(A), I13(B)
7 B
W–B
W–B
(∗1)
Connector
Junction
(RHD)
W–B
7 A
(LHD)
5 6F
W–B
1 HH1
W–B
(∗2)
17 IH3
1 6F
W–B
8
12 13 W–B
(LHD)
1 H41
Junction
Connector
W–B
W–B
(∗1)
W–B
W–B
B3 H1 H2
134
HIACE (EM04Z2E)
1
2
W–B L
14 5B
A23
Turn Signal Lamp
(Front LH)
1
2
W–B W–B L–R
31 5B
A1
A1
Turn Signal Lamp
(Front RH)
W–B W–B
a1
9 Za1
9 ZU1
GR
U2
Turn
3
6
4
W G G
Junction
15 5A
4 TU1
Connector
U1
2
Rear Combination
Lamp (RH)
W–B
W–B
5 TY2
3 TU3 (∗3)
3 TU2 (∗4)
HIACE (EM04Z2E)
W–B
Turn
6
4
W W Y
27 5A
Y1
4 TY2
T16
Rear Combination
Lamp (LH)
135
Turn Signal and Hazard Warning Light
: Parts Location
48 (LHD) H28 A 49 (LHD) 50 (LHD)
A1 T16
58 (RHD) H29 B 59 (RHD) 60 (RHD)
48 (LHD) 49 (LHD) 51 (LHD)
A23 H41 U1
58 (RHD) 59 (RHD) 61 (RHD)
H9 59 (RHD) I4 49 (LHD) 51 (LHD)
U2
49 (LHD) I12 A 49 (LHD) 61 (RHD)
H20
59 (RHD) I13 B 49 (LHD)

1I 25 Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
5A 30 Roof Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5J 30
31
5S
6F

66 (LHD)
74 (RHD)
HH1
68 (LHD)
TU1
76 (RHD)
68 (LHD)
TU2 Roof Wire and Roof No.2 Wire (Rear of the Left Side of the Roof Panel)
76 (RHD)
68 (LHD)
TU3
76 (RHD)
68 (LHD)
TY2 Roof Wire and Luggage Room No.3 Wire (Left Quarter Panel)
76 (RHD)
68 (LHD)
ZU1 Back Door No.1 Wire and Roof No.2 Wire (Rear of the Right Side of the Roof Panel)
76 (RHD)
68 (LHD)
Za1 Back Door No.1 Wire and Back Door No.2 Wire (Right Side of Back Door)
76 (RHD)
: Ground Points
66 (LHD)
A1 Dash Panel Right
74 (RHD)
62 (*1)
63 (*2)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
66 (LHD)
H1
74 (RHD) Instrument Panel Reinforcement
H2 66 (LHD)
136
HIACE (EM04Z2E)
: Ground Points
68 (LHD)
Y1 Left Quarter Panel
76 (RHD)
68 (LHD)
a1 Back Door Right
76 (RHD)
137
HIACE (EM04Z2E)
Stop Light
(BAT)
10A
STOP
3 5J 4 5J 4 5A 24 5A
R–W
G–B
∗ 1 : w/ Rear Wiper
∗ 2 : w/o Rear Wiper
L
∗ 4 : Except ∗3
17 HB4
T14(A), T15(B) 8 A (∗4)

Junction Connector 8 B (∗3)
G–B
2 A 3 A (∗4)
2 6 B 7 B (∗3)
Stop Lamp SW
L
B2
1
L–B
R–W
3 dT1
19 HB4 8 TU1
R–W
L–B
L
L
Rear Combination
Stop Lamp
3 1
Rear Combination
Center
Lamp (RH)
Stop
d1
Lamp (LH)
Stop
2
U1
T16
6
6
(∗1)
(∗2)
W
B
W
1 dT1 2 dT1
W
W–B
W–B
GR
GR
W–B
(∗1)
(∗2)
BR
3 TU2 (∗4)
9 ZU1 1 3 2 3 TU3 (∗3) 4 TY2
W–B
W–B
U2
Junction 3 TY1 3 TY2
Connector
9 Za1 5 TY2
W
W–B
(∗1)
(∗2)
BR
W–B
W–B
a1 Y1 Y1
138
HIACE (EM04Z2E)
: Parts Location
48 (LHD) T15 B 60 (RHD) 51 (LHD)
B2 U2
58 (RHD) 50 (LHD) 61 (RHD)
T16
50 (LHD) 60 (RHD) 51 (LHD)
T14 A d1
60 (RHD) 51 (LHD) 61 (RHD)
U1
T15 B 50 (LHD) 61 (RHD)

5J 30 Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)

66 (LHD)
74 (RHD)
68 (LHD)
TU1
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
TU3
76 (RHD)
68 (LHD)
TY1
76 (RHD)
Roof Wire and Luggage Room No.3 Wire (Left Quarter Panel)
68 (LHD)
TY2
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
dT1 Back Door No.3 Wire and Roof Wire (Rear of the Left Side of the Roof Panel)
76 (RHD)
: Ground Points
68 (LHD)
76 (RHD)
68 (LHD)
a1 Back Door Right
76 (RHD)
139
HIACE (EM04Z2E)
Back-Up Light
(IG) ∗ 2 : Except ∗1
10A
GAUGE
2 5E
L–R
5 DB4
L–R
T14(A), T15(B)
(M/T)
(A/T)
L–R
Junction Connector
Back–Up Lamp SW
2 2
D37
Park/Neutral 9 A 10 A 11 A (∗2)
RB RL
Position SW 9 B 10 B 11 B (∗1)
R
D36
1 1
R
(M/T)
BR
L
L 3 5A
(A/T)
P
1 DB4
1 5E 2 TU1
L
BR
Rear Combination
Rear Combination
1 1
Back–Up
Back–Up
Lamp (RH)
Lamp (LH)
T16
U1
6 6
W
W
W–B
GR
W–B
GR
9 ZU1 1 3 2 3 TU2 (∗2) 4 TY2

3 TU3 (∗1)
W–B
W–B
U2
Junction
Connector
9 Za1 5 TY2
W
W–B
W–B
a1 Y1
140
HIACE (EM04Z2E)
: Parts Location
44 (*1) 45 (*2) 50 (LHD)
T16
45 (*2) D37 52 (*4) 60 (RHD)
46 (*3) 55 (*5) 51 (LHD)
D36 U1
52 (*4) 50 (LHD) 61 (RHD)
T14 A
55 (*5) 60 (RHD) 51 (LHD)
U2
56 (*6) 50 (LHD) 61 (RHD)
T15 B
D37 44 (*1) 60 (RHD)


62 (*1)
63 (*2)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
68 (LHD)
TU1
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
TU3
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
: Ground Points
68 (LHD)
76 (RHD)
68 (LHD)
a1 Back Door Right
76 (RHD)
141
HIACE (EM04Z2E)
Taillight
∗ 1 : Except ∗2
(BAT) ∗ 3 : Before Oct. 2006 Production, RHD From Oct. 2006 Production
120A G
MAIN4
BR
1 1G
LG
BR
LG
G
B–G
T14(A), T15(B) 4 A (∗1)

1 5G 6 5Q 12 5A 19 5A
12 A 5 A (∗1)
10A PANEL 12 B 5 B (∗2)
Y
10A TAIL
T–LP Relay
B
9 TU1
9 5S 15 5B 4 5E
Y
7 TU1
(2TR–FE)
R–G
G
6 ZU1
Rear Combination
5
Lamp (RH)
Tail
2 15
Connector
H42
Junction
U1
Junction
B35
Connector 6
1 16
6 Za1
R–G
(2TR–FE)
G
14 A (LHD)
Y
15 B (RHD)
W–B
H T EL A
15 A
W
1
Clearance Lamp
Clearance Lamp
OFF ELS
License Plate Lamp
(Front RH)
2 2
(Front LH)
Control SW
Tail
3 2
A21
Connector
Light
B9(A)
A6
Head
Junction
1 1 Engine ECU
U2
a4
AUTO
2 1
H28(A), H29(B) 16 A (LHD)
W–B
W–B
GR
BR
9 ZU1
W–B
2
Connector
Junction
W–B
7 6F
a1
1
9 Za1
W–B
1 6F
W–B
W–B
W–B
H2 A1 a1 a1
142
HIACE (EM04Z2E)
(IG)
G 10A
MET IGN
BR
1 5M
B–R
G
10 6
ILL+ IG+
BR
H20
Tail
Combination
Rear Combination
5 Meter
Lamp (LH)
Tail
T16
E1
6
7
W–B
W–B
(∗3)
W
3 TU2 (∗1) 1 HH1

3 TU3 (∗2)
W–B
W–B
(∗4)
5 TY2 4 TY2
W–B
(∗3)
W–B
Y1 H2
143
HIACE (EM04Z2E)
Taillight
: Parts Location
48 (LHD) H28 A 49 (LHD) 51 (LHD)
A6 U1
58 (RHD) H29 B 59 (RHD) 61 (RHD)
48 (LHD) 49 (LHD) 51 (LHD)
A21 H42 U2
58 (RHD) 59 (RHD) 61 (RHD)
44 (*1) 50 (LHD) 51 (LHD)
B9 A T14 A a1
52 (*4) 60 (RHD) 61 (RHD)
44 (*1) 50 (LHD) 51 (LHD)
B35 T15 B a4
52 (*4) 60 (RHD) 61 (RHD)
49 (LHD) 50 (LHD)
H20 T16
59 (RHD) 60 (RHD)

5E
5G
5M
5Q 31 Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5S
6F

HH1
68 (LHD)
TU1
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
TU3
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
: Ground Points
66 (LHD)
A1 Dash Panel Right
74 (RHD)
66 (LHD)
74 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
a1 Back Door Right
76 (RHD)
144
HIACE (EM04Z2E)
Memo
145
HIACE (EM04Z2E)
Illumination
(BAT)
120A
MAIN4
1 1G
B–G
1 5G
9 5Q 8 5Q 9 5P 2 5Q 10 5P
T–LP Relay
10A
PANEL
9 5S
(RHD)
(LHD)
G
G
Rear Window Defogger SW
Hazard Warning Signal SW

Blower SW (Front A/C)
Ashtray Illumination
Room Lamp SW
4 5 5 2 1 1
A/C SW
H14
H16
H17
H13
H10
H9
R–G
5 6 4 1 2 2
2
H42
Junction
Connector
(RHD)
(LHD)
W–B
W–B
W–B
W–B
W–B
W–B
1
R–G
14 A (LHD)
15 B (RHD)
A H T EL 3 2 7 11 9
OFF
Control SW
Tail 1 H41 13
Junction
Connector
W–B
Light
Head
AUTO
H28(A), H29(B) 16 A (LHD) 17 IH3 (LHD)

Combination SW 9 B (RHD) 17 IH4 (RHD)
W–B
W–B
W–B W–B
W–B W–B
H1
146
HIACE (EM04Z2E)
1
2
W–B G
W–B
W–B
W–B
(∗3) (∗3)
I16
Power Slide Door Main SW
1
2
W–B G
(∗3) (∗3)
I15
Power Slide Door Control SW
6
3
W–B G
I9
Headlamp Leveling SW
W–B
1
3
W–B G G
10 A
9 B
3 B
4 A
I3
W–B Rear Fog Lamp SW
12 A
(∗3)
G
2 A
2
1
W–B W–B W–B G (∗3)
7 A
7 B
(LHD) (LHD)
I12(A), I13(B) I4
Junction Hazard Warning
Connector Signal SW G
3 A
W–B
I12(A), I13(B)
(∗3)
2
1
W–B G
Junction Connector
(RHD) (RHD)
I5
Room Lamp SW
W–B
2
1
W–B G
HIACE (EM04Z2E)
I6
Idle–Up SW
2
1
W–B G
I7
Door Lock
G
Control SW
BR BR BR G G
7 A
10 A
1 B
ILL+
GND
∗ 3 : w/ Power Slide Door
2 IH3 (LHD)
2 IH4 (RHD)
BR G G G
6 B
1 A
4 D
17 D
7 5Q
TAIL
GND1
BR
W–B
W–B
4 IH3 (LHD)
I2(A), I18(D)
4 IH4 (RHD)
Radio Receiver Assembly
147
Illumination
until Apr. 2009 Production (BAT)
10A
DOME
R
8 5P 6 5P 6 5Q
18 5E
8 5S
G
G
A/T Shift Lever Illumination
Rear Blower SW (Main)
1 2
R
H11
H21
4 1
10 5
ILL+ B
W–B
W–B
Illumination
Illumination
Pointer
Combination Meter
H20
12 6F 14 6F
E1
7
10 6F
W–B
W–B
W–B
(∗1)
(∗2)
9 6F
7
W–B 1 HH1
6F
W–B
(∗1)
1 6F
W–B
BR
W–B
W–B
(∗2)
H2
148
HIACE (EM04Z2E)
: Parts Location
H9 59 (RHD) 49 (LHD) 49 (LHD)
H21 I6
H10 49 (LHD) 59 (RHD) 57 (RHD)
49 (LHD) H28 A 49 (LHD) 49 (LHD)
H11 I7
59 (RHD) H29 B 59 (RHD) 57 (RHD)
49 (LHD) 49 (LHD) I9 49 (LHD)
H13 H41
59 (RHD) 59 (RHD) 49 (LHD)
I12 A
49 (LHD) 49 (LHD) 57 (RHD)
H14 H42
59 (RHD) 59 (RHD) 49 (LHD)
I13 B
49 (LHD) 49 (LHD) 57 (RHD)
H16 I2 A
59 (RHD) 57 (RHD) I15 57 (RHD)
49 (LHD) 49 (LHD) I16 57 (RHD)
H17 I3
59 (RHD) 57 (RHD) I18 D 57 (RHD)
49 (LHD) I4 49 (LHD)
H20
59 (RHD) I5 57 (RHD)
: Relay Blocks

5E
5G
5P
5S
6F

HH1
IH3 66 (LHD)
IH4 74 (RHD)
: Ground Points
66 (LHD)
H1
74 (RHD)
66 (LHD)
H2
74 (RHD)
149
HIACE (EM04Z2E)
1
12
W–B W–B
H1
150
(∗3) (∗3)
H41
Junction
Connector
2
1
R–B R–W R R
1 MB1
5 MB1
(∗5) (∗5) (∗5) (∗5)
M3
R–B R–B Step Lamp (RH) R R
(∗5)
6 Bq1
5 Bq1
R–B
(∗5 ∗6) (∗5 ∗6) (∗5 ∗6) (∗5 ∗6)
Interior Light
R–B R–B R
(∗5 ∗7) (∗5 ∗7) (∗5 ∗7)
2 B (∗9)
2 A (∗8)
1 B (∗9)
1 A (∗8)
B33(A), q6(B)
R
(∗5)
(∗5)
R–B
Step Lamp (LH)
4
3
L R
(LHD) (LHD)
W–B W–B H10
B3
7 5M
(∗3) (∗3) Room Lamp SW
4
3
W–B W L L L
12 5E 28 5A
1 5K
11 IH2
4 BT1
25 HB2
(∗3) (∗3) (RHD) (RHD)
I5
R Room Lamp SW
R
(RHD)
(∗4)
R R(RHD)
1 IH2
23 HB2
R
R
(LHD)
3
3 BT1
(∗4)
(∗3)
W–B
B
(∗3)
1
W–B(∗3)
HIACE (EM04Z2E)
T1
G(∗1 ∗3 ∗9)
ON
3
OFF
2
GR(∗2 ∗3 ∗9) GR
DOOR
(∗2 ∗3)
Junction Connector
1
T19
T8
Diode
W–B
No. 9)
Room Lamp (Center)
(∗1 ∗3)
(∗1 ∗3 ∗8)
(Door Courtesy
1
2
ON
3
3
1
4
OFF L–B R
2
Y(∗1 ∗3 ∗9) (∗1 ∗3) (∗1 ∗3)

DOOR
T2
Junction
Connector
T13
Y
R
G
G
G
(∗5)
R(∗4)
Room Lamp (Rear)
(∗2 ∗9)
R–B(∗5)
W–B(∗3)
(∗1 ∗3 ∗9)
(∗1 ∗3 ∗9)
(∗1 ∗3 ∗8)
Y(∗1 ∗3 ∗8)
GR(∗2 ∗3 ∗8)
GR(∗2 ∗4 ∗9)
∗ 1 : Super Long
∗ 2 : Except Super Long
∗ 3 : w/ Map Lamp
∗ 4 : Except ∗3
∗ 5 : w/ Step Lamp
∗ 7 : w/o Power Slide Door
R R
(∗5) (∗5)
T1
Junction Connector
1 L–B
2
L–B
(∗1)
(∗4)
(∗3)
R
L
(∗4)
R
(∗4)
R
2 2
Room Lamp (Center)
T5
Room Lamp (Rear)

3 Map Lamp
DOOR
DOOR
2
OFF
OFF
ON
ON
T12
Room Lamp (Front)

T7
1 1
DOOR
L–B(∗1 ∗4 ∗9)
DOOR
OFF
(∗1 ∗3 ∗8)
ON
Y
T4
(∗1 ∗4 ∗8)
(∗1 ∗4 ∗8)
1
L–B
2 1
W–B
(∗3)
Y
(∗1 ∗3 ∗8)
(∗1 ∗3 ∗8) 2 3
LG(∗4 ∗9)
G
(∗4 ∗8)
LG
G
(Door Courtesy No. 10)
(∗1 ∗3 ∗8) T3 1
Junction
(∗2 ∗4 ∗8)
Connector 1
GR
Y(∗1 ∗4 ∗9)
(∗1 ∗4 ∗8)
GR(∗2 ∗4 ∗9)
GR
Diode
T20
2
GR(∗2 ∗3 ∗8) G(∗1 ∗3 ∗8)
G G(∗1 ∗4 ∗8) 2 1
Y(∗4 ∗9)
(∗2 ∗9)
G T18
(∗1 ∗9) Diode LG
(Door Courtesy
No. 7) (∗3)
21 BT1
2 22 BT1
G 1 3
(∗1 ∗3 ∗9)
T21 R–L
Diode
R(∗4) R–B (Door Courtesy No. 11) R–B
W–B(∗3)
R–B(∗5) R–B
(∗5)
Y
(∗1 ∗3 ∗9)
151
HIACE (EM04Z2E)
Interior Light
(BAT) (BAT) (IG)
10A 10A 7. 5A Integration Relay

DOME ECU–B ECU–IG
SIG ECUB DCTY PCTY
2 2 5 6 26 20
2 2
R
R
W–R
(∗5) 17 5E 27 5E 10 5E 7 5D
W–R
R
R–G
18 5E
R–G(RHD)
R–G(LHD)
(RHD)
(LHD)
R–L
R–L
5
L–B
5K
8 5S 4 5P
R–G
R
(∗14)
(∗15)
R–G
R
1 1
Door Courtesy SW
Door Courtesy SW
Cylinder Lamp
2
Ignition Key
Transponder Key
1
ILL+
(Front RH)
(Front LH)
13 6D 14 6D
Cylinder
Ignition
H24
Lamp
Key
Amplifier
B22
B26
2
H43
ILL–
6
16 6D 15 6D
(∗14)
(∗15)
R–Y
R–Y
R
R–G
R–G
H20
Combination
5 Meter
(Door Courtesy
1
B
Door
No. 2)
Diode
H36
2
R–G
SW2 SW
4 12
R–G
Y–R Y–R
∗10 : 6 Speaker
∗11 : Except ∗10
∗12 : Standard Body Standard Roof
∗13 : Except ∗12
∗14 : w/ Engine Immobiliser System
∗15 : w/o Engine Immobiliser System
R–L R–L
R–B R–B
R–B R–B
(∗5) (∗5)
152
HIACE (EM04Z2E)
(∗5)
R–L
R–B
R–B
Y–R
R–G
2
H35
Diode
No. 1)
1
Integration Relay
(Door Courtesy
Y–R 2
1
3
R–L R–L
6 6A
5 6A
H37
Diode
R–B
R–L R–L R–L R–L
7 6A
4 6A
12 5D
22 HB2
22
R–B R–B R–B
6 6C
4 6C
8 5D
RCTY
R–B R–B
5 6C
21 HB2
T17
Diode
R–B R–B (Door Courtesy
7 6C
18 HB2
(∗5) (∗5 ∗8) No. 6)
2
1
1
2
L R–B
(∗5 ∗9) (∗5 ∗9)
H45 G
HIACE (EM04Z2E)
W
(∗10)
a1 Diode (∗10)
Junction
Connector
1
3
2
1
W–B B LG LG G G
a1
9 5A
2 Za1
2 ZU1
(∗11)
a2
11 TU2 (∗13)
11 TU3 (∗12)
Back Door
Courtesy SW
1
2
1
B B B W
18 5A
3 UX1
X2 T9
4 TU2 (∗13)
4 TU3 (∗12)
Door Courtesy SW Diode

(Slide Door RH) (Door Courtesy No. 5)
1
2
1
R R W
30 5A
4 TY1
Y3 T6
(Slide Door LH) (Door Courtesy No. 4)
153
Interior Light
: Parts Location
50 (LHD) I5 57 (RHD) 50 (LHD)
B22 T13
60 (RHD) 50 (LHD) 60 (RHD)
M3
50 (LHD) 60 (RHD) 50 (LHD)
B26 T17
60 (RHD) 48 (LHD) 60 (RHD)
T1
50 (LHD) 58 (RHD) 48 (LHD)
B33 A T18
60 (RHD) 48 (LHD) 58 (RHD)
T2
H10 49 (LHD) 58 (RHD) 48 (LHD)
T19
49 (LHD) 48 (LHD) 58 (RHD)
H20 T3
59 (RHD) 58 (RHD) 48 (LHD)
T20
49 (LHD) 50 (LHD) 58 (RHD)
H24 T4
59 (RHD) 60 (RHD) 48 (LHD)
T21
49 (LHD) 50 (LHD) 58 (RHD)
H35 T5
59 (RHD) 60 (RHD) 51 (LHD)
X2
49 (LHD) 50 (LHD) 61 (RHD)
H36 T6
59 (RHD) 60 (RHD) 51 (LHD)
Y3
49 (LHD) 50 (LHD) 61 (RHD)
H37 T7
59 (RHD) 60 (RHD) 51 (LHD)
a1
49 (LHD) 50 (LHD) 61 (RHD)
H41 T8
59 (RHD) 60 (RHD) 51 (LHD)
a2
49 (LHD) 50 (LHD) 61 (RHD)
H43 T9
59 (RHD) 60 (RHD) q6 B 61 (RHD)
49 (LHD) 50 (LHD)
H45 T12
59 (RHD) 60 (RHD)
: Relay Blocks

5K 30 Roof Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5M
5P 31 Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5S
6A
6C
6D

66 (LHD)
BT1 Engine Room Main Wire and Roof Wire (Cowl Side Panel LH)
74 (RHD)
Bq1 76 (RHD) Engine Room Main Wire and Step Rear Floor LH Wire (Side Step Left)
66 (LHD)
74 (RHD)
IH2 74 (RHD) Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Reinforcement LH)
62 (*1)
MB1 Pillar No.1 Wire and Engine Room Main Wire (RH Side Battery Room)
63 (*2)
154
HIACE (EM04Z2E)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
68 (LHD)
TU2
76 (RHD)
Roof Wire and Roof No.2 Wire (Rear of the Left Side of the Roof Panel)
68 (LHD)
TU3
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
UX1 Roof No.2 Wire and Luggage Room No.2 Wire (Right Quarter Panel)
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
: Ground Points
62 (*1)
63 (*2)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
66 (LHD)
74 (RHD)
68 (LHD)
a1 Back Door Right
76 (RHD)
155
HIACE (EM04Z2E)
Automatic Light Control and Light Auto Turn Off System
(BAT) (IG) ∗ 1 : Before Apr. 2009 Production

∗ 2 : From Apr. 2009 Production
10A 7. 5A
ECU–B ECU–IG
2
W–R
H7(A)
5 Integration Relay
SIG
ECUB GND AUTO CLTB CLTE CLTS

6 1 10 A 26 A 24 A 25 A
W
P
B
17 5E 12 5E 7 5M
W–R
W–B
W–B
3 IH2 14 IH2 4 IH2

(∗1)
(∗2)
BE
O
R–B
W
P
B
R–G
1 3 4
CLTB CLTE CLTS
12 A 13 A 14 A (LHD)
13 B 14 B 15 B (RHD)
A EL H T
I10
Automatic Light
OFF Control Sensor
Control SW
Tail
Light
Head
W–B
AUTO
H28(A), H29(B) 16 A (LHD)

W–B
12
Connector
Junction
H41
R–B
1
7 6F
W–B
W–B
1 6F R–G
W–B
B3 H1 H2
156
HIACE (EM04Z2E)
R–B
R–G
1
26
R–G
27 5E
DCTY
(LHD)
B22
Door Courtesy SW
(Front LH)
1
R–L
H7(A)
(RHD)
B26
Door Courtesy SW
(Front RH)
Integration Relay
1
2
19
R–G R
3 5H
TRLY
H40
Diode
(Automatic Light
Control No. 2)
R–B
4 6E
1
2
1
2
R–B R–B R–Y
14 A
7 6E
6 6E
HRLY
H38 H39
Diode Diode
(Headlight) (Automatic Light
Control No. 1)
HIACE (EM04Z2E)
2
1
2
R–W R–W R–W W–R W–R

4
4
2
3 6E
1 6E
3 HB2
(BAT)
5
3
W–L W–R
4
4
40A
HEAD
HEAD
Relay
1
R–G
3
2
R–G R–G B–G

9 5S
1 5G
1 1G
(BAT)
H42
120A
Junction
MAIN4
Connector
T–LP
Relay
157
Automatic Light Control and Light Auto Turn Off System
: Parts Location
B22 50 (LHD) 49 (LHD) 49 (LHD)
H38 H41
B26 60 (RHD) 59 (RHD) 59 (RHD)
49 (LHD) 49 (LHD) 49 (LHD)
H7 A H39 H42
59 (RHD) 59 (RHD) 59 (RHD)
H28 A 49 (LHD) 49 (LHD) 49 (LHD)
H40 I10
H29 B 59 (RHD) 59 (RHD) 57 (RHD)
: Relay Blocks

5E
5G
5H 30
31
5S
6E
6F

66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
: Ground Points
63 (*2)
70 (*4)
66 (LHD)
H1
74 (RHD)
66 (LHD)
H2
74 (RHD)
158
HIACE (EM04Z2E)
Memo
159
HIACE (EM04Z2E)
Headlight Beam Level Control
(BAT)
40A
HEAD
W–L
2
4
2
W–R
1
15A
W–R
W–R
HEAD LH
4 4 2
1 3 4
L
HEAD Relay
L
2 5
8 AB1 6 HA1
4 4
L
1
L
L
(Headlight)
R–W
W–L
Diode
H38
L 18 IH1
2 3 HB2
R–W
R–W
R–B
L
I9
L
Headlamp
7 6E 3 6E 1 6E 2 Leveling SW
3 3
B
LH T RH T
Headlamp Leveling
4 6E 2 6E Headlamp Leveling
Motor (RH)
Motor (LH)
R–W
R–B
LH E LHIG RH E RHIG
A20
A8
13 8
1 2 1 2
RH+ LH+ E
EL H T HF HU HL A
5 4 1
W–B
W–B
R–Y
L–B
OFF
W–B
R–Y
L–B
Control SW
Tail
8
Connector
2 IH2 13 IH2 12 IH2

Light
Head
Junction
A25
AUTO
W–B
R–Y
L–B
3
Low
Dimmer SW
W–B
High
16 HA1 31 HA1 7 HA1
Flash
16 H28
Combination SW
W–B
L–B
W–B
7 6F
W–B W–B
1 6F
W–B
W–B
H2 A1
160
HIACE (EM04Z2E)
: Parts Location
A8 48 (LHD) A25 48 (LHD) H38 49 (LHD)
A20 48 (LHD) H28 49 (LHD) I9 49 (LHD)
: Relay Blocks

6E
6F

AB1 66 (LHD) Cowl to Head Lamp Wire and Engine Room Main Wire (Left Side of the Instrument Panel J/B)
HA1 66 (LHD) Instrument Panel Wire and Cowl to Head Lamp Wire (Under the Instrument Panel J/B)
HB2 66 (LHD) Instrument Panel Wire and Engine Room Main Wire (Near the Steering Column)
IH1
66 (LHD) Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Reinforcement LH)
IH2
: Ground Points
A1 66 (LHD) Dash Panel Right
H2 66 (LHD) Instrument Panel Reinforcement
161
HIACE (EM04Z2E)
Front Wiper and Washer
∗ 1 : w/ INT Time SW
(IG) H30(A), (B) (IG)

Combination SW
25A Front Wiper SW Front Washer SW 20A

WIP WSH
+2 +1 +B +S INT1 INT2 B1 WF E
MIST Off
OFF On
2 5H 12 5B
INT
L–R
LO
L
HI
Washer Motor
1
Windshield
17 6E
M
(∗1)
(∗1)
A17
2
18 6E 19 6E
Wiper Relay
B
L
+B +2 +1 +S E WF
17 A 8 A 7 A 16 A 2 A 11 A (LHD) 10 HA2
11 B 2 B 3 B 12 B 8 B 17 B (RHD)
B
W–B
B
L–R
20 6E 4 6F
R–B
22 6E 1 6F
W–B
L–R
6 HA2 11 HA2 9 HA2 4 HA2

R–B
L–R
4 A 1 A 3 A 2 A (LHD)
3 B 5 B 1 B 2 B (RHD)
+2 +1 +S B
E
A11(A), (B) 5 A (LHD)
Windshield Wiper Motor 4 B (RHD)
W–B
W–B
A1 H2
162
HIACE (EM04Z2E)
: Parts Location
A 48 (LHD) 48 (LHD) A 49 (LHD)
A11 A17 H30
B 58 (RHD) 58 (RHD) B 59 (RHD)

6E
6F

66 (LHD)
74 (RHD)
: Ground Points
66 (LHD)
A1 Dash Panel Right
74 (RHD)
66 (LHD)
74 (RHD)
163
HIACE (EM04Z2E)
Rear Wiper and Washer
(IG)
15A
RR H30(A), (B)
WIP–WSH Combination SW
WR +1R C1R E
Washer
Rear Wiper and

10 5A 9 5H
OFF
Washer SW
R–L
LO
HI
2 HA2
B–R
On+Washer
12 A 10 A 13 A 2 A (LHD)
16 B 18 B 15 B 8 B (RHD)
R–L
W–B
B–R
R–B
L–R
A18
M Rear Washer
Motor
2
B–R
5 HA2 8 HB2 15 HB2

B–R
R–B
L–R
15 BT1 9 BT1
B–R
LG
P
7 dT1 5 dT1 6 dT1
W–B
B–R
LG
P
1 3 2
B S +1
4 6F
1 6F
Rear Wiper
Relay
W–B
M Rear Wiper
Motor
d2
Rear Wiper Motor
H2
164
HIACE (EM04Z2E)
: Parts Location
48 (LHD) A 49 (LHD) 51 (LHD)
A18 H30 d2
58 (RHD) B 59 (RHD) 61 (RHD)

6F

66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
68 (LHD)
76 (RHD)
: Ground Points
66 (LHD)
74 (RHD)
165
HIACE (EM04Z2E)
Power Window (LHD)
(IG) (BAT) (BAT)
10A 120A 30A L5

GAUGE MAIN4 DOOR
Power Window Master SW
1 1G 1 5H
BW B UH DH
7 6 13 15
B–G
W–R
R–L
R
L
1 5G
7 HA2 5 LA3 1 LA3 5 LA1 2 LA1
W–R
W–L
R–L
L
PWR
Relay
W–L
W–L
R–L
L
30A
PWR
2 1 KA3 5 KA1 2 KA1
12 5E 7 5M 36 5B
R–L
L
W–L L
W–B
W–B
4 5 2
B SU SD
Power Window SW
Down
Up
U D (Front RH)
K6
12
Connector
3 1
Junction
H41
G
Y
2 1
U D
W–B
K4
Power Window
Regulator Motor
(Front RH)
14
W–B W–B W–B
W–B
HA2
B3 H1
166
HIACE (EM04Z2E)
L5
VCC PLS2 PLS GND U D E CTY

3 17 14 2 4 9 1 11
W–B
BR
W
R
Y
Y
L
3 LA1 6 LA3
4 3 5 6 2 1
R–L
W–B
VCC PLS2 PLS E U D
22 HA1
M
R–L
8 6A
L4
Power Window Regulator Motor (Front LH)
4 6A 5 6A
R–L
R–L
(Door Courtesy
1
No. 1)
Diode
H35
2
R–G
14 6D
W–B
7
Connector
Junction
13 6D
A25
R–G
R–L
12 5D 7 5D
W–B
10 5E 27 5E
R–G
R–L
Door Courtesy SW
Door Courtesy SW
1 1
W–B W–B W–B
(Front RH)
(Front LH)
B26
B22
A2 A1
167
HIACE (EM04Z2E)
Power Window (LHD)
: Parts Location
A25 48 (LHD) H35 49 (LHD) K6 50 (LHD)
B22 50 (LHD) H41 49 (LHD) L4 50 (LHD)
B26 50 (LHD) K4 50 (LHD) L5 50 (LHD)

5E
5G
5H 30
5M 31
6A
6D

HA1
66 (LHD) Instrument Panel Wire and Cowl to Head Lamp Wire (Under the Instrument Panel J/B)
HA2
KA1
67 (LHD) Front Door RH Wire and Cowl to Head Lamp Wire (Right Kick Panel)
KA3
LA1
67 (LHD) Front Door LH Wire and Cowl to Head Lamp Wire (Left Kick Panel)
LA3
: Ground Points
A2 66 (LHD) Dash Panel Left
62 (*1)
64 (*3)
H1 66 (LHD) Instrument Panel Reinforcement
168
HIACE (EM04Z2E)
Memo
169
HIACE (EM04Z2E)
Power Window (RHD)
(IG) (BAT) (BAT)
10A 120A 30A K5

GAUGE MAIN4 DOOR
1 1G 1 5H
BW B UH DH
7 6 13 15
B–G
W–R
R–L
R
L
1 5G
7 HA2 5 KA3 1 KA3 5 KA1 2 KA1
W–R
W–L
R–L
L
PWR
Relay
W–L
W–L
R–L
L
30A
PWR
2 1 LA3 5 LA1 2 LA1
12 5E 7 5M 36 5B
R–L
L
L
W–L
W–B
W–B
4 5 2
B SU SD
Power Window SW
Down
Up
(Front LH)
U D
L6
3 1
12
Connector
Junction
G
Y
H41
1
2 1
U D
M
W–B
L4
Power Window
Regulator Motor
(Front LH)
14
W–B W–B W–B
W–B
HA2
B3 H1
170
HIACE (EM04Z2E)
K5
VCC PLS2 PLS GND U D E CTY

3 17 14 2 4 9 1 11
W–B
BR
W
R
Y
Y
L
3 KA1 6 KA3
4 3 5 6 2 1
R–L
W–B
VCC PLS2 PLS E U D
22 HA1
M
R–L
8 6A
K4
Power Window Regulator Motor (Front RH)
4 6A 5 6A
R–L
R–L
(Door Courtesy
1
No. 1)
Diode
H35
2
R–G
14 6D
13 6D
R–G
R–L
12 5D 7 5D
10 5E 27 5E
R–G
R–L
W–B
Door Courtesy SW
Door Courtesy SW
1 1
W–B W–B W–B
(Front RH)
(Front LH)
B22
B26
A2 A1
171
HIACE (EM04Z2E)
Power Window (RHD)
: Parts Location
B22 60 (RHD) H41 59 (RHD) L4 60 (RHD)
B26 60 (RHD) K4 60 (RHD) L6 60 (RHD)
H35 59 (RHD) K5 60 (RHD)

5E
5G
5H 30
5M 31
6A
6D

HA1
74 (RHD) Instrument Panel Wire and Cowl to Head Lamp Wire (Under the Instrument Panel J/B)
HA2
KA1
75 (RHD) Front Door RH Wire and Cowl to Head Lamp Wire (Right Kick Panel)
KA3
LA1
75 (RHD) Front Door LH Wire and Cowl to Head Lamp Wire (Left Kick Panel)
LA3
: Ground Points
A1 74 (RHD) Dash Panel Right
A2 74 (RHD) Dash Panel Left
70 (*4)
72 (*6)
172
HIACE (EM04Z2E)
Memo
173
HIACE (EM04Z2E)
L
5
4
12
174
Lock L–W L–W
L1
24 5B
1 LA1
ALTB
(BAT)
(∗1) (∗1)
3
7
1
W–B W–B W–B
A1
3 LA1
E
(∗1) (∗1) (∗1)
30A
8
10
A25 L–Y L–Y
DOOR
23 5B
4 LA1
UL1
Junction Unlock (∗1) (∗1)
UL
Connector
L5
5
Power Window
SIG
(IG)
Master SW
7. 5A
ECU–IG
H41
L
3
Junction Lock L–W L–W
6 5H
9 IH3
Connector (∗2) (∗2)
1
6
13
W–B W–B W–B W–B
7 A
7 B
H1
17 IH3
E
(∗2) (∗2) (∗2)
5
I12(A), I13(B) L–Y L–Y
12
7 5H
Door Lock Control (LHD)
18 IH3
Junction Unlock (∗2) (∗2)
UL
Connector
6
2
W–R
2
17 5E
(BAT)
ECUB
I7
W–B
Door Lock
Control SW
10A
ECU–B
1
W–B
7 5M
GND
W–B W–B
12 5E
B3
W–B W–B
21 A
3 6F
DBKL
(∗3) (∗3)
HIACE (EM04Z2E)
H7(A)
1
2
9
W–B W–B W–B Y–B Y
1 6F
9 6F
10 6F
16 6F
H2
12 6C
11 6C
14 5H
KSW
Integration Relay
(A/T) (A/T)
H26
Unlock
Warning SW
1
2
W–B W–B Y
19 6F
17 6F
13 6C
(M/T) (M/T)
H27
Unlock
Warning SW
W–B
∗ 1 : w/ Power Window
∗ 2 : w/o Power Window
∗ 3 : w/ Wireless Door Lock Control
∗ 4 : 6 Speaker
∗ 5 : Except ∗4
∗ 9 : Except ∗8
H7(A)
Integration Relay
DCTY PCTY RCTY

26 20 22
27 5E 10 5E 9 5A 18 5A 30 5A
W
(∗4)
(∗5)
W
G
W
R–G
R–L
(Door Courtesy
(Door Courtesy
(Door Courtesy
1 1 1
(∗4)
G
11 TU3 (∗8)
No. 6)
No. 5)
No. 4)
Diode
Diode
Diode
T17
11 TU2 (∗9)
T9
T6
2 2 2
G
R
B
Door Courtesy SW
Door Courtesy SW
1 1
4 TU3 (∗8) 4 TY1
(Front RH)
(Front LH)
2 ZU1 4 TU2 (∗9)

B22
B26
LG
2 Za1 3 UX1
LG
Door Courtesy SW
Door Courtesy SW
1 1 1
(Slide Door RH)
(Slide Door LH)

Courtesy SW
Back Door
X2
Y3
a2
2
B
3
Connector
Junction
a1
1
W–B
W–B W–B
a1
175
HIACE (EM04Z2E)
H7(A)
Integration Relay
LSWD L2 UL2 ACT+ ACT–

20 A 14 16 2 3
(∗3 ∗6)
W
21 5B 22 5B 33 5B 34 5B 3 5B 4 5B
7 HH1
L–W
L–W
L–Y
L–Y
R
L
(∗3 ∗7)
W
R
(∗3 ∗6)
W
11 HA1
L–W
L–W
L–Y
L–Y
LG
LG
LG
R
R
L
L
(∗3)
W
2 LA3 3 LA3 7 LA3 7 LA2 6 LA2 2 LA2 3 KA3 7 KA3 7 KA2 6 KA2 2 KA2 25 HA1
W–B
G(∗1)
G(∗1)
L–W
L–W
L–Y
L–Y
(∗3)
(∗2)
(∗2)
BR
BR
W
R
L
8 9 10 4 1 7 6 5 4 1 8
LSSR L UL L UL E L UL L UL E
Unlock Detection
Key Unlock
Key Unlock
Key Lock
Key Lock
M M
L1 K1
Door Lock Assembly (Front LH) Door Lock Assembly (Front RH)
W–B
176
HIACE (EM04Z2E)
26 5E 11 5E 25 5A 29 5A
R
L
R
L
L 1 TU1 6 TU1
R
R
L
R
L
2 NB1 5 NB1 4 MB1 3 MB1

R
R
L
1 ZU1 5 ZU1
2 3 2 3
R
L
L–B
L–B
G
1 Za1 5 Za1
L–B
L–B
G
P
L
1 2 1 2
Junction (Male RH)
Junction (Male LH)
Slide Door Control
Slide Door Control
2 1
M M
Lock Assembly
Door Lock Motor Assembly Door Lock Motor Assembly

(Slide Door LH) (Slide Door RH) M
Back Door
M1
N1
a3
177
HIACE (EM04Z2E)
: Parts Location
A25 48 (LHD) I12 A 49 (LHD) T9 50 (LHD)
B22 50 (LHD) I13 B 49 (LHD) T17 50 (LHD)
B26 50 (LHD) K1 50 (LHD) X2 51 (LHD)
H7 A 49 (LHD) L1 50 (LHD) Y3 51 (LHD)
H26 49 (LHD) L5 50 (LHD) a1 51 (LHD)
H27 49 (LHD) M1 50 (LHD) a2 51 (LHD)
H41 49 (LHD) N1 50 (LHD) a3 51 (LHD)
I7 49 (LHD) T6 50 (LHD)
: Relay Blocks

5H 30
5M 31
6C
6F

HH1 66 (LHD) Instrument Panel Wire and Instrument Panel Wire (Near the Steering Column)
KA2
KA3
LA1
LA2 67 (LHD) Front Door LH Wire and Cowl to Head Lamp Wire (Left Kick Panel)
LA3
62 (*1)
MB1 63 (*2) Pillar No.1 Wire and Engine Room Main Wire (RH Side Battery Room)
64 (*3)
62 (*1)
NB1 63 (*2) Pillar No.2 Wire and Engine Room Main Wire (LH Side Battery Room)
64 (*3)
TU1
TU3
UX1 68 (LHD) Roof No.2 Wire and Luggage Room No.2 Wire (Right Quarter Panel)
: Ground Points
62 (*1)
64 (*3)
178
HIACE (EM04Z2E)
: Ground Points
H1
H2
179
HIACE (EM04Z2E)
180
L
5
4
12
Lock L–W L–W
L1
6 5B
1 KA1
ALTB
(BAT)
(∗1) (∗1)
1
W–B W–B W–B
A1
3 KA1
E
(∗1) (∗1) (∗1)
30A
8
10
L–Y L–Y
DOOR
5 5B
UL1
4 KA1
Unlock (∗1) (∗1)
UL
K5
5
Power Window
SIG
(IG)
Master SW
7. 5A
H41
Door Lock Control (RHD)
L
3
ECU–IG
Junction Lock L–W L–W
6 5H
9 IH4
Connector (∗2) (∗2)
1
6
13
7 A
7 B
H1
17 IH4
E
(∗2) (∗2) (∗2)
5
I12(A), I13(B) L–Y L–Y
12
7 5H
18 IH4
6
2
Junction Unlock (∗2) (∗2) W–R

2
UL
17 5E
Connector
(BAT)
ECUB
I7
W–B
Door Lock
10A
Control SW
ECU–B
W–B
7 5M
GND
W–B W–B
HIACE (EM04Z2E)
12 5E
B3
H7(A)
Integration Relay
1
2
9
W–B Y–B Y
16 6F
12 6C
11 6C
14 5H
KSW
(A/T) (A/T)
H26
Unlock
Warning SW
1
2
W–B W–B W–B Y
1 6F
9 6F
10 6F
17 6F
H2
13 6C
(M/T) (M/T)
H27
Unlock
Warning SW
∗ 4 : w/o Wireless Door Lock Control
∗ 5 : 2TR–FE ∗4, 1KD–FTV ∗4, 2KD–FTV ∗4
∗ 6 : 6 Speaker
∗ 7 : Except ∗6
∗12 : Except ∗11
H7(A)
Integration Relay
DCTY PCTY RCTY DBKL

26 20 22 21 A
27 5E 10 5E 9 5A 18 5A 30 5A
W
(∗6)
(∗3)
LG
W
W
(Door Courtesy
(Door Courtesy
1 1 1
R–G
R–L
(∗7)
G
No. 5)
No. 4)
Diode
Diode
Diode
T17
T9
T6
2 2 2
G
R
B
(∗6)
11 TU3 4 TU3 (∗11) 4 TY1 7 HB2

11 TU2 4 TU2 (∗12)
Door Courtesy SW
Door Courtesy SW
1 1
(Front RH)
(Front LH)
G
B26
B22
2 ZU1 (∗5)
LG
LG
LG
R
B
2 Za1 3 UX1
LG
Door Courtesy SW
Door Courtesy SW
1 1 1 2
(Slide Door RH)
(Slide Door LH)
(Driver' s Side)
Courtesy SW
Back Door
Front Seat
Inner Belt
B11
X2
Y3
a2
2 1
B
3
Connector
Junction
a1
1
LG
W–B
W–B
(∗5)
a1 B2
181
HIACE (EM04Z2E)
H7(A)
Integration Relay
LSWD L2 UL2 ACT+ ACT–

20 A 14 16 2 3
(∗3 ∗13)
W
3 5B 4 5B 33 5B 34 5B 21 5B 22 5B
(∗3 ∗14)
W
7 HH1
L–W
L–W
L–Y
L–Y
R
L
R
(∗3 ∗13)
W
11 HA1
L–W
L–W
L–Y
L–Y
LG
LG
LG
R
R
L
L
(∗3)
W
2 KA3 3 KA3 7 KA3 7 KA2 6 KA2 2 KA2 3 LA3 7 LA3 7 LA2 6 LA2 2 LA2 25 HA1
(∗10)
W–B
BR(∗2)
G(∗1)
G(∗1)
L–W
L–W
L–Y
L–Y
(∗3)
(∗2)
BR
W
R
L
(∗5)
LG
19 6F
7 6 5 4 1 8 9 10 4 1 7
10 6F
Unlock Detection
Key Unlock
Key Unlock
Key Lock
Key Lock
(∗10)
W–B
M M
9 6F
K1 L1
Door Lock Assembly (Front RH) Door Lock Assembly (Front LH)
1 6F
LG
(∗10)
W–B
(∗5)
H2
182
HIACE (EM04Z2E)
∗ 4 : w/o Wireless Door Lock Control
∗ 5 : 2TR–FE ∗4, 1KD–FTV ∗4, 2KD–FTV ∗4
∗10 : 2TR–FE ∗3, 1KD–FTV ∗3, 2KD–FTV ∗3, 5L–E
∗13 : Before Apr. 2009 Production
∗14 : From Apr. 2009 Production
26 5E 11 5E 25 5A 29 5A
R
L
R
L
R
(∗9)
L 1 TU1 6 TU1
(∗9)
(∗8)
(∗8)
R
(∗9)
(∗9)
(∗9)
(∗9)
R
R
L
7 Bq1 2 Bq1
(∗8)
(∗8)
2 NB1 5 NB1 4 MB1 3 MB1

R
1 ZU1 5 ZU1
4 oq1 5 oq1
(∗9)
(∗9)
(∗9)
(∗9)
R
R
L
L
(∗8)
(∗8)
R
2 3 2 3 1 Za1 5 Za1
18 po1 9 po1
L–B
L–B
G
G
(∗8)
(∗8)
R
Slide Door Control Junction (Male RH)

Slide Door Control Junction (Male LH)
P
L
L–B
L–B
3 2
G
UL L
2 1
1 2 1 2
Lock Assembly
M
M M M
Back Door

M1
(Slide Door LH) (Slide Door RH)

N1
a3
p5
Slide Door Lock
Remote Control Assembly
183
HIACE (EM04Z2E)
: Parts Location
52 (*4) I7 57 (RHD) T9 60 (RHD)
B11 54 (*5) I12 A 57 (RHD) T17 60 (RHD)
56 (*6) I13 B 57 (RHD) X2 61 (RHD)
B22 60 (RHD) K1 60 (RHD) Y3 61 (RHD)
B26 60 (RHD) K5 60 (RHD) a1 61 (RHD)
H7 A 59 (RHD) L1 60 (RHD) a2 61 (RHD)
H26 59 (RHD) M1 60 (RHD) a3 61 (RHD)
H27 59 (RHD) N1 60 (RHD) p5 61 (RHD)
H41 59 (RHD) T6 60 (RHD)
: Relay Blocks

5H 30
5M 31
6C
6F

HA1 74 (RHD) Instrument Panel Wire and Cowl to Head Lamp Wire (Under the Instrument Panel J/B)
IH4 74 (RHD) Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Reinforcement RH)
KA1
KA2 75 (RHD) Front Door RH Wire and Cowl to Head Lamp Wire (Right Kick Panel)
KA3
LA2
75 (RHD) Front Door LH Wire and Cowl to Head Lamp Wire (Left Kick Panel)
LA3
70 (*4)
72 (*6)
70 (*4)
72 (*6)
TU1
TU2 76 (RHD) Roof Wire and Roof No.2 Wire (Rear of the Left Side of the Roof Panel)
TU3
TY1 76 (RHD) Roof Wire and Luggage Room No.3 Wire (Left Quarter Panel)
UX1 76 (RHD) Roof No.2 Wire and Luggage Room No.2 Wire (Right Quarter Panel)
ZU1 76 (RHD) Back Door No.1 Wire and Roof No.2 Wire (Rear of the Right Side of the Roof Panel)
Za1 76 (RHD) Back Door No.1 Wire and Back Door No.2 Wire (Right Side of Back Door)
oq1 76 (RHD) Rear Door No.2 Wire and Step Rear Floor LH Wire (Side Step Left)
po1 76 (RHD) Slide Door Wire and Rear Door No.2 Wire (Near the Slide Door Handle LH)
184
HIACE (EM04Z2E)
: Ground Points
A1 74 (RHD) Dash Panel Right
70 (*4)
B2 71 (*5) Front Floor Panel Right
72 (*6)
70 (*4)
72 (*6)
H1
H2
a1 76 (RHD) Back Door Right
185
HIACE (EM04Z2E)
Power Slide Door
p3
Door Control SW
(BAT) (BAT) (BAT) (IG)
30A RR DOOR
10A ECU–B
25A PSD
ECU–IG
7. 5A
Lock Release Motor
Lock Release
2 2 2
Position SW
Position SW
M
2 2 2 11 5C
Initial
W–R
B–R
B–R
W
GR
R
B
B
8 Bq1 1 Bq1 4 Bq1 6 HB4
CSW– PSW– PSW+ CSW+ UL L
3 1 2 4 6 5
B–R
BR
BR
Connector
16 oq1
Junction
R
Y
B
L
B34
W
BR
Door Opening Relay

10 12 5 3 1
B–R
E PSW CSW UL L 2 po1
4 Bq2
GND RACT CLS B p2
2 4 11 6
R–B
W–B
W–R
B–R
B–R
R–B
q3(A), q4(B)
Door Control Relay
(Power Slide Door) 12 B 8 A 9 B
ECUB B IG
RACT CSW MSW BZR+ GND GND SGND HSW

10 A 16 B 17 B 1 B 21 B 7 A 13 B 8 B
Y–G
R–B
R–B
B–Y
W–B
BR
W–B
W–B
P
17 oq1 8 Bq2 9 Bq2 9 oq1 1 oq1

1 1
Connector
Warning Buzzer
Junction
Y–G
R–B
B–Y
BR
P
BZR+
H41
Slide Door
13
11 po1 10 HB4 21 HB4 BZR– 16 po1 6 po1
q2
W–B
2
B–Y
Y–G
BR
W–B
2 IH2 12 IH2 17 IH4 1

Handle SW
Slide Door
W–B
B–Y
p4
Power Slide Door
Power Slide Door
3 4 7
Connector
2
Junction
W–B
Control SW
I12
Main SW
12
3 oq1
I15
I16
4 5
W–B
W–B
W–B
W–B
W–B
W–B
W–B
BR
8 po1 3 Bq1
W–B
W–B
BR
p1 H1 B3
186
HIACE (EM04Z2E)
(IG)
10A GAUGE
1 6D
2 5E
L–R
2 6D
Diode (Power Slide Door)
5 DB4
R–W
L–R
3
2
Park/Neutral
Position SW
PL RB
H47
q1(A), q5(B)
D37
Slide Door Motor Assembly

P 2
R–W
R–Y
Magnetic Clutch Slide Door Sensor

6
R–W
9 HB4 Slide Door Motor
M
8 DB5
R–Y
SD+ GND SD– CL+ CL– DSV DS1 DS2 DSG

R–W
3 B 1 B 2 B 5 B 4 B 3 A 4 A 2 A 1 A
10 Bq2
48 HB1
Y–R
R–Y
Y–B
BR
LG
R
B
L
q3(A), q4(B)
Door Control Relay
7 B 4 A 9 A 3 A 5 A 1 A 11 B 24 B 23 B 10 B (Power Slide Door)
P SD+ SEL SD– CL+ CL– DSV DS1 DS2 DSG
DC+ DC– POS POL HAF FUL DLSW

2 A 6 A 19 B 18 B 4 B 5 B 22 B
G–W
L–W
L–R
P
Y
L
13 oq1 12 oq1 7 oq1 6 oq1 11 oq1 10 oq1 8 oq1
G–W
L–W
L–R
P
Y
L
1 po1 10 po1 13 po1 4 po1 12 po1 3 po1 15 po1

G–W
L–W
L–R
P
Y
L
2 1 10 9 3 4 4
Slide Door Lock
ACT+ ACT– HND POL HAF FUL

G
B
R
Position SW
Position SW
p5
L
1
2 1
Initial
Pawl
M Handle SW
Slide Door
Latch SW
W
Closer Motor
L
L
BR
L
E1
p1 8
Slide Door Lock Assembly
BR
BR BR BR
187
HIACE (EM04Z2E)
Power Slide Door
∗ 1 : Before Apr. 2009 Production
∗ 2 : From Apr. 2009 Production (BAT) (IG) (BAT)
GAUGE
ECU–B
DOME
H7(A)
10A
10A
10A
Integration Relay
2 2
LSD1 PRG RDA ECUB 2 2 5E 2

5 A 6 A 7 A 6
W–R
R
L–R
17 5E 18 5E
B–L
W
B
20 HB4 9 HB1 8 HB1 W–R

8 5S
R
H20
W–R
B–L
W
B
5 Combination Meter
B
1 Bq2 13 BT1 7 BT1 6 BT1
Speedometer
B–L
GR
q3(A), q4(B)
Door Control Relay 1 TY1 10 TY1 2 TY1
(Power Slide Door) 6 B
MPX1
SI E3 +S E1
15 29 9 7
OS SPD
GR
BR
14 B 26 B
P
58 HB1 22 HB1
P–L
G
W–B
P–L
(∗1)
L–R
3 2 5
BR
P
PRG RDA +B
2 oq1 2 Bq2 5 DB4 3 DB4 7 DB4 1 HH1
GND
G
Y2
L–R
P–L
1
BR
P
Door Control Receiver

7 po1
3 2
W–B
W–B
SI E
(∗2)
G
1 5
Connector
Junction
IG+
OS
B35
W–B
D38
(∗1)
1
Speed
Power Slide Door Sensor
4
Sensor
L–R
P–L
24 5E
OSG
p6
2
14 5D
P–L
BR
Y1 H2
188
HIACE (EM04Z2E)
: Parts Location
B34 58 (RHD) H41 59 (RHD) p4 61 (RHD)
52 (*4) H47 59 (RHD) p5 61 (RHD)
B35
54 (*5) I12 57 (RHD) p6 61 (RHD)
52 (*4) I15 57 (RHD) q1 A 61 (RHD)
D37
55 (*5) I16 57 (RHD) q2 61 (RHD)
52 (*4) Y2 61 (RHD) q3 A 61 (RHD)
D38
55 (*5) p1 61 (RHD) q4 B 61 (RHD)
H7 A 59 (RHD) p2 61 (RHD) q5 B 61 (RHD)
H20 59 (RHD) p3 61 (RHD)
: Relay Blocks

5C
5D
6D 38 (RHD) Instrument Panel Wire and Center J/B (Instrument Panel Reinforcement RH)

BT1 74 (RHD) Engine Room Main Wire and Roof Wire (Cowl Side Panel LH)
Bq1
76 (RHD) Engine Room Main Wire and Step Rear Floor LH Wire (Side Step Left)
Bq2
70 (*4)
DB4
71 (*5)
70 (*4)
DB5
71 (*5)
HB4 74 (RHD) Instrument Panel Wire and Engine Room Main Wire (Under the Instrument Panel J/B)
IH2 74 (RHD) Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Reinforcement LH)
IH4 74 (RHD) Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Reinforcement RH)
: Ground Points
70 (*4)
71 (*5)
H1
H2
Y1 76 (RHD) Left Quarter Panel
p1 76 (RHD) Near the Slide Door Handle LH
189
HIACE (EM04Z2E)
Door Closer
(BAT)
30A
RR DOOR
2
B–R
7
B–R B–R B–R
MB1
B–R
B32
1 Door Control Relay (LH)
B
E SW RLY PCTY
3 4 5 2
W–B
W–B
L
6 NB1 1 NB1
W–B
5 BT1
W–B
5 1 4
N1
P
Slide Door Control
W
R
L
Junction (Male LH)
(Door Courtesy
3
No. 4)
Diode
W
R
L
T6
2
L
1 2
R
R
B
7 5 Slide Door Closer Relay

GND +B
DC+ DC– POS SWE PAWL HALF FULL

2 1 10 8 9 3 4 4 TY1
G
B
L
W–B
Position SW
Position SW
2 1
Initial
M Handle SW
4 NB1
Pawl
Slide Door
W
Closer Motor
L L
W–B
W–B
W–B
Door Courtesy SW
Latch SW
1
(Slide Door LH)
W–B
Y3
B3
190
HIACE (EM04Z2E)
∗ 2 : Except ∗1
B–R
B–R
M2
1 Door Control Relay (RH)
B
E SW RLY PCTY
3 4 5 2
L–B
W–B
W–B
6 MB1
W–B
L–B
5 1 4
M1
Slide Door Control 23 BT1
W
R
L
Junction (Male RH)

W
R
L
L–B
L
1 2 (Door Courtesy
3
R
B
7 5 Slide Door Closer Relay

No. 5)
Diode
GND +B
T9
2
DC+ DC– POS SWE PAWL HALF FULL
2 1 10 8 9 3 4
B
G
B
L
R
Position SW
4 TU3 (∗1)
W–B
W–B
Position SW
4 TU2 (∗2)
2 1
Initial
M Handle SW
Pawl
8 MB1 2 MB1 Slide Door

W
Closer Motor
L L 3 UX1
W–B
W–B
Door Courtesy SW
Latch SW
1
(Slide Door RH)
W–B
X2
B2
191
HIACE (EM04Z2E)
Door Closer
: Parts Location
50 (LHD) 50 (LHD) 51 (LHD)
B32 N1 X2
60 (RHD) 60 (RHD) 61 (RHD)
50 (LHD) 50 (LHD) 51 (LHD)
M1 T6 Y3
60 (RHD) 60 (RHD) 61 (RHD)
50 (LHD) 50 (LHD)
M2 T9
60 (RHD) 60 (RHD)
: Relay Blocks

66 (LHD)
74 (RHD)
63 (*2)
71 (*5)
63 (*2)
71 (*5)
68 (LHD)
TU2
76 (RHD)
68 (LHD)
TU3
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
: Ground Points
63 (*2)
71 (*5)
63 (*2)
71 (*5)
192
HIACE (EM04Z2E)
Memo
193
HIACE (EM04Z2E)
Wireless Door Lock Control (LHD)
(BAT) (IG) ∗ 2 : w/o Power Window
30A 7. 5A
DOOR ECU–IG
H7(A)
4 5 Integration Relay
ALTB SIG
LSWD ACT+ ACT–

20 A 2 3
(∗3)
W
(∗4)
W
33 5B 34 5B
7 HH1
R
L
R
(∗3)
W
11 HA1
LG
LG
R
R
L
L
W
2 LA3 7 LA2 6 LA2 2 LA2 25 HA1 7 KA2 6 KA2

G(∗1)
W–B
(∗2)
BR
W
R
L
8 4 1 7 4 1
LSSR L UL E L UL
Unlock Detection
M M
L1 K1
Door Lock Assembly (Front LH) Door Lock Assembly (Front RH)
W–B
194
HIACE (EM04Z2E)
H7(A)
Integration Relay
KSW
9
14 5H
Y
11 6C
26 5E 11 5E 25 5A 29 5A
R
L
R
L
12 6C 13 6C
R
(M/T)
(A/T)
Y–B
Y
Unlock Warning SW
Unlock Warning SW
L 1 TU1 6 TU1
2 2
H26
H27
R
R
L
1 1
(M/T)
(A/T)
W–B
W–B
2 NB1 5 NB1 4 MB1 3 MB1 1 ZU1 5 ZU1
16 6F 17 6F
R
R
L
2 3 2 3
R
L
L–B
L–B
19 6F 10 6F
G
1 Za1 5 Za1
W–B
W–B
L–B
L–B
G
P
L
1 2 1 2 9 6F
2 1
M M M
1 6F
W–B
N1 M1 a3
Slide Door Control Junction Slide Door Control Junction Back Door Lock Assembly
(Male LH) (Male RH)
W–B
H2
195
HIACE (EM04Z2E)
196
H41
Junction
Connector
1
1
12
W–B W–B W–B
H1
7 5M
GND
∗
∗
∗
∗
8
7
6
5
W–B W–B
12 5E
B3
: Except ∗7
: Except ∗5
: 6 Speaker
1
26
R–G
27 5E
DCTY
B22
: Standard Body Standard Roof
Door Courtesy SW
(Front LH)
H7(A)
1
20
R–L
10 5E
PCTY
Integration Relay
B26
Door Courtesy SW
(Front RH)
T17
Diode
(Door Courtesy
No. 6)
2
1
G
W
(∗5)
a1 (∗5)
Junction
HIACE (EM04Z2E)
Connector
1
3
2
1
22
W–B B LG LG G G
a1
9 5A
2 Za1
2 ZU1
11 TU2
11 TU3
RCTY
(∗6)
a2
Back Door
Courtesy SW
1
2
1
B B B W
18 5A
3 UX1
X2 T9
4 TU2 (∗8)
4 TU3 (∗7)

1
2
1
R R W
30 5A
4 TY1
Y3 T6
(Slide Door LH) (Door Courtesy
No. 4)
(BAT)
10A
ECU–B
W–R
H7(A)
Integration Relay
HAZ PRG RDA ECUB

25 6 A 7 A 6
8 17 5E
W
B
EHW
9 HB1 8 HB1 W–R W–R

Flasher
Relay
W–R
W
B
13 BT1 7 BT1 6 BT1

GR
1 TY1 10 TY1 2 TY1

GR
3 2 5
PRG RDA +B
GND
Y2 1
W–B
Y1
197
HIACE (EM04Z2E)
: Parts Location
B22 50 (LHD) L1 50 (LHD) Y2 51 (LHD)
B26 50 (LHD) M1 50 (LHD) Y3 51 (LHD)
H7 A 49 (LHD) N1 50 (LHD) a1 51 (LHD)
H26 49 (LHD) T6 50 (LHD) a2 51 (LHD)
H27 49 (LHD) T9 50 (LHD) a3 51 (LHD)
H41 49 (LHD) T17 50 (LHD)
K1 50 (LHD) X2 51 (LHD)
: Relay Blocks

5H 30
5M 31
6C
6F

BT1 66 (LHD) Engine Room Main Wire and Roof Wire (Cowl Side Panel LH)
HB1 66 (LHD) Instrument Panel Wire and Engine Room Main Wire (Near the Steering Column)
KA2 67 (LHD) Front Door RH Wire and Cowl to Head Lamp Wire (Right Kick Panel)
LA2
LA3
TU1
TU3
UX1 68 (LHD) Roof No.2 Wire and Luggage Room No.2 Wire (Right Quarter Panel)
: Ground Points
H1
H2
198
HIACE (EM04Z2E)
Memo
199
HIACE (EM04Z2E)
Wireless Door Lock Control (RHD)
(BAT) (IG)
30A 7. 5A
DOOR ECU–IG
H7(A)
ALTB SIG
LSWD ACT+ ACT–

20 A 2 3
(∗9)
W
33 5B 34 5B
(∗10)
W
R
L
7 HH1
R
(∗9)
W
11 HA1
LG
R
L
LG
R
L
W
25 HA1 7 LA2 6 LA2
2 KA3 7 KA2 6 KA2 2 KA2

W–B
19 6F
R
L
G(∗1)
(∗2)
BR
W
R
L
10 6F 4 1
L UL
7 4 1 8
W–B
LSSR L UL E
Unlock Detection
M
9 6F
M
L1
1 6F Door Lock Assembly
(Front LH)
K1
Door Lock Assembly (Front RH)
W–B
H2
200
HIACE (EM04Z2E)
∗10 : From Apr. 2009 Production
H7(A)
Integration Relay
26 5E 11 5E 25 5A 29 5A
R
R
L
L
R
(∗4)
L 1 TU1 6 TU1
(∗4)
(∗3)
(∗3)
R
(∗4)
(∗4)
(∗4)
(∗4)
R
R
L
7 Bq1 2 Bq1
(∗3)
(∗3)
R
2 NB1 5 NB1 4 MB1 3 MB1

1 ZU1 5 ZU1
4 oq1 5 oq1
(∗3)
(∗3)
(∗4)
(∗4)
(∗4)
(∗4)
R
R
L
18 po1 9 po1 2 3 2 3 1 Za1 5 Za1

L–B
L–B
G
G
(∗3)
(∗3)
R
P
L
3 2
L–B
L–B
G
UL L
Back Door Lock Assembly
1 2 1 2
2 1
M
Junction (Male RH)
Junction (Male LH)
Slide Door Control
Slide Door Control
M M M

p5 (Slide Door LH) (Slide Door RH)
a3
Slide Door Lock

M1
N1
201
HIACE (EM04Z2E)
202
H41
Junction
Connector
1
1
12
W–B W–B W–B
H1
7 5M
GND
W–B W–B
12 5E
B3
1
26
R–L
27 5E
DCTY
B26
H7(A)
Door Courtesy SW
(Front RH)
1
20
R–G
10 5E
PCTY
Integration Relay
B22
Door Courtesy SW T17

(Front LH)
Diode
2
1
∗
∗
∗
∗
8
7
6
5
G
W
(∗5)
(∗5)
a1
: Except ∗7
: Except ∗5
: 6 Speaker
Junction
HIACE (EM04Z2E)
Connector
1
3
2
1
22
W–B B LG LG G G
a1
9 5A
2 Za1
2 ZU1
11 TU2
11 TU3
RCTY
(∗6)
a2
Back Door
Courtesy SW
: Standard Body Standard Roof
1
2
1
B B B W
18 5A
3 UX1
X2 T9
4 TU2 (∗8)
4 TU3 (∗7)
1
2
1
R R W
30 5A
4 TY1
Y3 T6
(Slide Door LH) (Door Courtesy No. 4)
(BAT)
10A
ECU–B
W–R
H7(A)
Integration Relay
KSW HAZ PRG RDA ECUB

9 25 6 A 7 A 6
8 17 5E
W
B
14 5H EHW
Y
9 HB1 8 HB1 W–R

Flasher
11 6C Relay
W–R
W
B
12 6C 13 6C
13 BT1 7 BT1 6 BT1
(M/T)
(A/T)
Y–B
Y
Unlock Warning SW
Unlock Warning SW
2 2
GR
O
H26
H27
1 1
1 TY1 10 TY1 2 TY1
(M/T)
(A/T)
W–B
W–B
16 6F 17 6F
GR
10 6F
3 2 5
W–B
PRG RDA +B
9 6F GND
Y2 1
1 6F
W–B
W–B
H2 Y1
203
HIACE (EM04Z2E)
: Parts Location
B22 60 (RHD) L1 60 (RHD) Y2 61 (RHD)
B26 60 (RHD) M1 60 (RHD) Y3 61 (RHD)
H7 A 59 (RHD) N1 60 (RHD) a1 61 (RHD)
H26 59 (RHD) T6 60 (RHD) a2 61 (RHD)
H27 59 (RHD) T9 60 (RHD) a3 61 (RHD)
H41 59 (RHD) T17 60 (RHD) p5 61 (RHD)
K1 60 (RHD) X2 61 (RHD)
: Relay Blocks

5H 30
5M 31
6C
6F

BT1 74 (RHD) Engine Room Main Wire and Roof Wire (Cowl Side Panel LH)
HA1 74 (RHD) Instrument Panel Wire and Cowl to Head Lamp Wire (Under the Instrument Panel J/B)
KA2
75 (RHD) Front Door RH Wire and Cowl to Head Lamp Wire (Right Kick Panel)
KA3
LA2 75 (RHD) Front Door LH Wire and Cowl to Head Lamp Wire (Left Kick Panel)
TU1
TU2 76 (RHD) Roof Wire and Roof No.2 Wire (Rear of the Left Side of the Roof Panel)
TU3
UX1 76 (RHD) Roof No.2 Wire and Luggage Room No.2 Wire (Right Quarter Panel)
ZU1 76 (RHD) Back Door No.1 Wire and Roof No.2 Wire (Rear of the Right Side of the Roof Panel)
Za1 76 (RHD) Back Door No.1 Wire and Back Door No.2 Wire (Right Side of Back Door)
: Ground Points
H1
H2
a1 76 (RHD) Back Door Right
204
HIACE (EM04Z2E)
Memo
205
HIACE (EM04Z2E)
ECT and A/T Indicator (2TR-FE)
(BAT) (IG) (BAT) (BAT)
10A ETCS
15A IGN
20A EFI
10A
STOP
2 2
9 5E 2
3 5J
MAIN
Relay
B–R
Y–B
B1
G–B
3 1J 2 1J 4 1J 1 1J
4 5J
17 HB4
R–W
W–B
G–Y
B–R
B–R
19 HB4 6 5E
G–B
R–W
2
R–W
1 2 3 4 5 6
Stop Lamp SW
19
Connector
Junction
B35
B2
W–R
W–L
Y–B
R–L
1 20
W
B
L
R–W
B–R
B–R
R–W
3 A 9 A 7 A 27 A 21 A 19 A 26 A 20 A 18 A 4 B
BATT IGSW +BM VCP2 EPA2 VPA2 VCPA EPA VPA STP
B7(B), B9(A), D1(D), D3(C)
Engine ECU
+B MREL VG E2G THA E2 VTA2 VTA1 M+ M– GE01 VC
1 A 8 A 28 C 30 C 29 C 28 D 19 D 20 D 5 D 4 D 8 D 18 D
Y–G
L–R
R
G–Y
B–R
B–R
(Shielded)
Y–R
L–B
1 DB1 2 DB1 8 DB1
G
L
Y–G
L–R
4 6 2 1
VTA2 VTA M+ M–
10 AB1 11 AB1 19 AB1
B–R
Y–G
L–R
9
Connector
R
Junction
D44
3 2 4 E2 VC
VG E2G THA 3 D29 5 10
Throttle Body
Assembly
L
+B E2
Y–R
1 A3 5
Air Flow
B–R
Y–R
Meter
2 3
Connector
Junction
3 AB1 20 AB1
D44
8
B–R
Y–R
Y–R
9 DB1
W–B
Y–R Y–R
B2
206
HIACE (EM04Z2E)
∗ 2 : Costa Rica, Egypt, El Salvador, G. C. C. , Guatemala, Honduras,
Malaysia, Nicaragua, Panama, Peru, Russia, South Africa, Ukraine, Vietnam
H18
A/C Amplifier Nicaragua, Niger, Panama, Peru, South Africa, Vietnam
∗ 7 : ∗1, ∗4 ∗5, ∗2 ∗3, ∗4 ∗6
CANH CANL
10 11
W
W
R
R
L
H3(A), H4(B), H5(C)
6 14
Junction Connector
CANH CANL
1 A 2 A 2 C 1 C
DLC3
Revolution Sensor
Revolution Sensor
TC H23 1 1
Transmission
Transmission
13
1 B 2 B
(Output)
(Input)
P–B
D42
D40
2 2
W
B
4 5H
11 HB4 22 HB4
G
L
7 5E
W
B
33 B 34 B 17 B 35 C 27 C 34 C 26 C
CANH CANL TC SP2+ SP2– NCO+ NCO–
B7(B), B9(A), D1(D), D3(C)
Engine ECU
THOC THW SLT+ SLT– SL S1 S2 E03 E01 E02 EC
22 D 32 D 12 C 13 C 11 C 9 C 8 C 4 C 7 D 6 D 22 A
W–B
W–B
W–B
(∗7)
BR
Water Temp. Sensor (Engine Coolant)
R–W
B–W
W–L
P–L
GR
LG
L
2 2
A/T Fluid Temp.
2 6 7 4 8
SLT+ SLT– SL S1 S2
Sensor
D39
D32
13
Connector
W
Junction
O
1 1
B36
Y–R
Y–R
12
W–B
W–B
W–B
D41
(∗7)
BR
ECT Solenoid
Y–R
D2 B2
207
HIACE (EM04Z2E)
(IG)
∗ 1 : Australia, Chile, China, Ecuador, Hong Kong, New Zealand, Thailand 10A
∗ 4 : From Oct. 2006 Production GAUGE
2 5E
L–R
5 DB4
R
L–R
L–R
R–Y
R
G–Y(∗9)
G–Y(∗8)
9 B 10 B 11 B
L 2 R B
G–Y(∗9)
G–Y(∗8)
B7(B), B9(A), D1(D), D3(C)

R–Y
Engine ECU
E1 ME01 E04 SPD 3
L–R
3 D 3 C 7 C 8 B 19 B
(∗1, ∗4 ∗5)
9 2 1
P–L
BR
BR
BR
NSSD ATD IG+
Speed Sensor
Shift Lock Control ECU
B
Transmission
7
Connector
Control SW
Junction
D38
E SI
B35
4 2 3
H22
19 HB2 AT3
BR
P
P–L
3
B
7 DB4 3 DB4
B
11
Connector
Junction
11 6E 13 6E
D43
BR
24 5E
P
22 HB1 58 HB1
12 6E
14 5D
(∗1, ∗4 ∗5)
P
W–B
P–L
BR
BR
BR
P–L
D2 D1
208
HIACE (EM04Z2E)
L–R
(BAT) D37
2 Park/Neutral Position SW
RB
10A
DOME
2
PL RL NL DL 2L LL
6 1 9 7 3 8
2
R–W
R–Y
GR
R
Y
L
R
8 DB5 1 DB4 4 DB5 6 DB5 5 DB5 1 DB5
R–Y
GR
L L
R
Y
Y
L
4 14 12 3 1
Connector
Connector
Junction
Junction
19 5E 1 5E
B34
B35
5 13 2
R–W
R–Y
GR
L–R
R
Y
11 5D
48 HB1 25 HB1 26 HB1 17 HB1 33 HB1
R–Y R–Y
G–Y(∗9)
R
Y
G–Y(∗8)
R–W
GR
B
G–Y(∗8)
L
G–Y(∗9)
15 12
Connector
Junction
18 5E 1 6D
H42
2 HH1
17 14
G–Y(∗8)
8 5S 3 6D
GR
R–W
R
R
Y
L
B
5 1 24 23 22 21 2 3
B 3 P R N D 2 L
Speedometer
D
P
3
SI E3 +S E1
15 29 9 H20 7
Combination Meter
P–L
BR
W–B
P
(∗8)
W–B(∗9)
P
1 HH1
BR
W–B
(∗8)
P–L
H2
209
HIACE (EM04Z2E)
: Parts Location
48 (LHD) D3 C 52 (*4) 44 (*1)
A3 D44
58 (RHD) 44 (*1) 52 (*4)
D29
48 (LHD) 52 (*4) 42, 49 (LHD)
B1 H3 A
58 (RHD) 44 (*1) 42, 59 (RHD)
D32
48 (LHD) 52 (*4) 42, 49 (LHD)
B2 H4 B
58 (RHD) 44 (*1) 42, 59 (RHD)
D37
44 (*1) 52 (*4) 42, 49 (LHD)
B7 B H5 C
52 (*4) 44 (*1) 42, 59 (RHD)
D38
44 (*1) 52 (*4) 49 (LHD)
B9 A H18
52 (*4) 44 (*1) 59 (RHD)
D39
48 (LHD) 52 (*4) 49 (LHD)
B34 H20
58 (RHD) 44 (*1) 59 (RHD)
D40
44 (*1) 52 (*4) 49 (LHD)
B35 H22
52 (*4) 44 (*1) 59 (RHD)
D41
44 (*1) 52 (*4) 49 (LHD)
B36 H23
52 (*4) 44 (*1) 59 (RHD)
D42
44 (*1) 52 (*4) 49 (LHD)
D1 D H42
52 (*4) 44 (*1) 59 (RHD)
D43
D3 C 44 (*1) 52 (*4)
: Relay Blocks

1J 25 Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
5H
30
5J Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5S 31
6D
6E

66 (LHD)
74 (RHD)
62 (*1)
DB1
70 (*4)
62 (*1)
70 (*4)
62 (*1)
DB5
70 (*4)
66 (LHD)
HB1
74 (RHD)
66 (LHD)
HB2
74 (RHD)
66 (LHD)
74 (RHD)
210
HIACE (EM04Z2E)
: Ground Points
62 (*1)
70 (*4)
62 (*1)
D1
70 (*4)
Engine Block
62 (*1)
D2
70 (*4)
66 (LHD)
74 (RHD)
211
HIACE (EM04Z2E)
ECT and A/T Indicator (1KD-FTV, 2KD-FTV)
(BAT)
25A
EFI
H18
A/C Amplifier
2
CANH CANL
10 11
Relay
MAIN
1 1J B–R
3 1J 2 1J 4 1J
B–R
W
L
H3(A), H4(B), H5(C)
Junction Connector
DLC3
H23
1 A 2 A CANL CANH SIL TC WFSE
W–B
G–Y
B–R
14 6 7 13 15
P–B
L–R
(∗2)
W
W
R
1 B 2 B 1 C 2 C
B–R
3 5S 4 5H
W
W
R
B
1
Connector
Junction
3
B37
11 HB4 22 HB4 7 HB4

2
3 5E 7 5E
W
B
L–R
(∗2)
W
P
B–R
2 B 24 B 23 B 18 A 11 A 19 A
BATT CANH CANL SIL TC WFSE
B7(B), B9(A), D1(D), D3(C)
Engine ECU
+B MREL EC E02 E01 LUSL VLU VC E2
1 A 8 A 6 B 6 D 7 D 4 C 29 C 18 D 28 D
W–B
G–Y
B–R
Y–R
R–L
L–B
BR
BR
D48(A), D50(B)
Throttle Body
B–R 1 A 3 B Assembly
DUTY VTA(∗1) 9 2 Connector
Junction
VAF(∗2)
D44
B(∗1) RSC(∗1) E(∗1)

+B(∗2) E1(∗2) E2(∗2) VC
11 8
13
Connector
2 A 3 A 2 B 1 B
Junction
B–R
B36
W–B
B–R
Y–R
Y–R
L–B
L–B
12
BR
W–B W–B 5 DB1 (∗1)

8 DB3 (∗2)
B–R
BR
BR
Y–R Y–R
B–R(∗1)
W–B
BR
B2 D3
212
HIACE (EM04Z2E)
∗ 1 : 1KD–FTV
(IG) (BAT) ∗ 2 : 2KD–FTV
15A 10A
IGN STOP
9 5E 7 5C 3 5J
B–R B–R
B–R
B–R B–R
R–W
G–B
B1 4 5J
Accelerator Position Sensor 17 HB4
R–W
L
19 HB4 6 5E
G–B
W
R–W
R–W
VCP2 EPA2 VPA2 VCPA EPA VPA 2
R–W
Stop Lamp SW
W
L
1 2 3 4 5 6
19
Connector
Junction
21 1 DB2 6 DB2
B35
B2
W–R
W–L
B–R
R–L
1 20
W
B
W
R–W
L
R–W
27 A 29 A 23 A 26 A 28 A 22 A 9 A 15 B 22 B 21 B
VCP2 EPA2 VPA2 VCPA EPA VPA IGSW STP CAN+ CAN–
B7(B), B9(A), D1(D), D3(C)
Engine ECU
EVG VG THA THF THW E1 SPD
32 C 24 C 31 D 29 D 19 D 7 C 17 B
B–L
(∗1)
(∗1)
R
R
B
(∗2)
Sensor (Air Cleaner)
11 DB1 10 DB1 8 DB1 2

R–W
R
P–L
BR
Inlet Air Temp.
B–L
(∗1)
(∗1)
R
B
Water Temp. Sensor
2 2
Fuel Temp. Sensor
(Engine Coolant)
11 AB1 10 AB1 19 AB1

A2
1
Y–R
Y–R
(∗2)
(∗1)
B–L
(∗1)
(∗1)
(∗1)
R
B
D46
D32
2 3 4 5
1 1
E2G VG THA E2 20 AB1
+B
Y–R
Y–R
Y–R
1 A27
Air Flow
B–R
(∗1)
Meter
3 AB1 9 DB1 P–L

BR
Y–R
D43
B–R
(∗1)
Junction
Y–R Y–R Y–R 11 Connector
BR 4 6 BR
B–R(∗1)
1
BR BR
BR
D3
213
HIACE (EM04Z2E)
(ST)
7. 5A
ST
B–W
B34
B–R Junction
7 Connector
B–R 11 B–W
ST Relay
R–W
9 3
B–W B–W
B–W
DB3
Revolution Sensor
2
R–W
B–R
B–R
Transmission
B34
R
Junction 4
L Connector
(Input)
L B
D40
16 18
W 5 DB2 3 DB1 (∗1) 26 HB2
Park/Neutral
1
Position SW
P
1 DB1 (∗2) 20
N
D37
R–W
B–W
B–R
B–R
W
Y
L
L
5
16 DO2 8 DO2 19 DO2 17 DO2 (∗1) 6 DO2 14 DO2 (∗1)

7
19 DO1 9 DO1 1 DO1 11 DO1 (∗2) 2 OB1 5 OB1 R 4 OB1 7 DO1 17 DO1 (∗2)
DB3
R–W
B–W
B–R
B–R
W
Y
L
L
20 A 21 A 14 A 5 A 6 A 11 C 12 C 3 C 2 C
CAN– CAN+ STP +B IG2 STA NSW NCO+ NCO–
O1(C), O2(B), O3(A)
Transmission Control ECU
E01 E1 SPD1 SLT+ SLT– SL S1 S2 THO
10 C 1 C 25 A 20 C 19 C 16 C 18 C 17 C 25 C
W–L
P–L
P–L
L–B
(∗1)
GR
GR
BR
BR
LG
25 DO2 9 DO2 2 DO2 5 DO2 13 DO2 24 DO2 10 DO2 11 DO2 (∗1) 12 DO2
20 DO1 10 DO1 2 DO1 6 DO1 16 DO1 14 DO1 12 DO1 13 DO1 (∗2)
W–L
P–L
L–B
(∗1)
GR
GR
LG
P–L
BR
BR
2 6 7 4 8 1
4 DB2 SLT+ SLT– SL S1 S2 OT+
W
O
B
P–L
P–L
OT–
BR D41 5
ECT Solenoid Y–B(∗1)
6
BR 7 4 P–L P–L
B35
Junction
Connector
214
HIACE (EM04Z2E)
∗ 1 : 1KD–FTV (IG)
∗ 2 : 2KD–FTV
until Apr. 2009 Production 10A
∗ 4 : LHD From Oct. 2006 Production, RHD From Apr. 2009 Production GAUGE
Y–B 2 5E
(∗1)
L–R
5 DB4
Y–B
7
1 Y Y
DB2
A/T Fluid Temp.
6
R–Y
OB1
3
L
Sensor
OB1
D56
L–R
2
Y–B
Y
L
L–R
18 DO2 1 DO2 3 DO2 4 DO2 (∗1)

5 DO1 15 DO1 3 DO1 4 DO1 (∗2)
R–Y
R–Y
Y–B
Y
L
G–Y(∗4)
24 C 23 C 10 B 11 B 8 B 9 B G–Y(∗3)
THOC E2 L 2 D R
B
O1(C), O2(B), O3(A)
R–Y

SP2+ SP2– 3
L–R
30 C 29 C 12 B 9 2
NSSD ATD
Transmission
1
Control SW
G
R
IG+
Speed Sensor
B
7 DO2 15 DO2 (∗1)

8 DO1 18 DO1 (∗2)
H22
D38
1 OB1 AT3 E SI
3 2 3
G
R
BR
B
P
Revolution Sensor
1 11 6E 13 6E
7 DB4 3 DB4
Transmission
19 HB2
(Output)
D42
BR
2 12 6E
B
22 HB1 58 HB1
P
Y–B(∗1)
BR
24 14
P–L P–L P–L P–L
5E 5D
215
HIACE (EM04Z2E)
L–R
(BAT)
D37
10A
DOME RB
PL RL NL DL 2L LL
2 6 1 9 7 3 8
R–W
R–Y
GR
R
R
Y
L
8 DB5 1 DB4 4 DB5 6 DB5 5 DB5 1 DB5
2
R R
DB2
Y
R–Y
R–Y R–Y
R
Y
Y
L L 6 4 14 12 3 1
Connector
L
Junction
Connector
Junction
B35
B34
19 5E 1 5E 5 13 2
R–W
R–Y
GR
L–R
R
Y
48 HB1 11 5D 25 HB1 26 HB1 17 HB1 33 HB1
R–Y R–Y
G–Y(∗4)
R
Y
G–Y(∗3)
G–Y
(∗3)
GR
B
R–W
15 12
Connector
Junction
18 5E 1 6D
H42
2 HH1
G–Y
(∗4)
17 14
G–Y
(∗3)
8 5S 3 6D
GR
R–W
R
R
B
Y
L
5 1 24 23 22 21 2 3
B 3 P R N D 2 L
Speedometer
D
P
3
SI E3 +S E1
15 29 9 H20 7
Combination Meter
P–L
BR
W–B
P
(∗3)

P until Apr. 2009 Production
W–B
(∗4)
BR 1 HH1
W–B
(∗3)
P–L
H2
216
HIACE (EM04Z2E)
: Parts Location
48 (LHD) 45 (*2) D56 55 (*5)
A2 D32
58 (RHD) 55 (*5) 42, 49 (LHD)
H3 A
A27 58 (RHD) 45 (*2) 42, 59 (RHD)
D37
48 (LHD) 55 (*5) 42, 49 (LHD)
B1 H4 B
58 (RHD) 45 (*2) 42, 59 (RHD)
D38
48 (LHD) 55 (*5) 42, 49 (LHD)
B2 H5 C
58 (RHD) 45 (*2) 42, 59 (RHD)
D40
45 (*2) 55 (*5) 49 (LHD)
B7 B H18
54 (*5) 45 (*2) 59 (RHD)
D41
45 (*2) 55 (*5) 49 (LHD)
B9 A H20
54 (*5) 45 (*2) 59 (RHD)
D42
48 (LHD) 55 (*5) 49 (LHD)
B34 H22
58 (RHD) 45 (*2) 59 (RHD)
D43
45 (*2) 55 (*5) 49 (LHD)
B35 H23
54 (*5) 45 (*2) 59 (RHD)
D44
45 (*2) 55 (*5) 49 (LHD)
B36 H42
54 (*5) 45 (*2) 59 (RHD)
D46
45 (*2) 55 (*5) 48 (LHD)
B37 O1 C
54 (*5) 45 (*2) 58 (RHD)
D48 A
45 (*2) 55 (*5) 48 (LHD)
D1 D O2 B
54 (*5) 45 (*2) 58 (RHD)
D50 B
45 (*2) 55 (*5) 48 (LHD)
D3 C O3 A
54 (*5) D56 45 (*2) 58 (RHD)
: Relay Blocks

1J 25 Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
5C
5D
5H
30
5J Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5S 31
6D
6E

66 (LHD)
74 (RHD)
63 (*2)
DB1
71 (*5)
63 (*2)
DB2
71 (*5) Engine Wire and Engine Room Main Wire (Front Side of Engine Room R/B No.1)
63 (*2)
DB3
71 (*5)
DB4 63 (*2)
217
HIACE (EM04Z2E)
DB4 71 (*5)
DB5
71 (*5)
63 (*2)
DO1
71 (*5) Engine Wire and Floor Wire (Front Floor Panel Right)
DO2 71 (*5)
66 (LHD)
HB1
74 (RHD)
66 (LHD)
HB2
74 (RHD)
66 (LHD)
74 (RHD)
HH1
67 (LHD) Floor Wire and Engine Room Main Wire (RH Side of Instrument Panel R/B)
OB1
75 (RHD) Floor Wire and Engine Room Main Wire (Near the Stop Lamp SW)
: Ground Points
63 (*2)
71 (*5)
63 (*2)
D3 Engine Block
71 (*5)
66 (LHD)
74 (RHD)
218
HIACE (EM04Z2E)
Memo
219
HIACE (EM04Z2E)
ABS
H23
(IG) DLC3 (BAT)
∗ 1 : 2TR–FE
7. 5A ∗ 3 : 5L–E 25A
ECU–IG ∗ 4 : Shielded ABS SOL
∗ 5 : w/ Engine Immobiliser System SIL TC TS
∗ 6 : w/o Engine Immobiliser System
∗ 7 : Except ∗8 7 13 12 2
(∗5)
W
7 5B 2
17 6C
P–B
L–Y
W–R
B–R
(∗6)
W
A24
1 Short Pin (Vacuum) 18 6C
IG1
(∗5)
W
3 5S 4 5H
GND2 GND1 IG1 SIL

6 3 4 5
26 5B 25 5B
W
W–B
W–B
B–R
P
22 AB1 15 AB1 14 AB1 18 HB4
W–R
B–R
L–Y
W
25 14 16 15 1
IG1 D/G TC TS +BS
B19
Skid Control ECU with Actuator
GND GND FL+ FL– FR+ FR–

2 24 9 8 31 30
W–B
W–B
(∗4)
(∗4)
W
W–B
W–B
R
R
L
W–B
W–B
12 AB1 21 AB1
W–B
W–B
W
R
R
L
W–B
Speed Sensor (Front RH)
Speed Sensor (Front LH)
2 2
W–B
B20
B18
1 1
W–B
W–B
W–B
W–B
W–B
W–B 18 17 20
6
W–B W–B 16 19 W–B
AB1
B36
A1 A2 Junction
Connector
220
HIACE (EM04Z2E)
W–B
W–B
n1
Speed Sensor (∗4) (∗4)
(Rear LH)
1
2
2
11
23
W R R W W
2 Pn1
RL+
6 BP2
+BM
(BAT)
40A
12
B G G
1 Pn1
RL–
5 BP2
ABS MTR
BR BR
1
2
4 BP2
R–W R–W G–B G–B 3 5J
19 HB4
17 HB4
(BAT)
B2
BR BR Stop Lamp SW
10A
1 BP2
STOP
B19
n2
Speed Sensor (∗4) (∗4)
(Rear RH)
R–W
1
2
33
10
W B B G–W G–W
4 5J
2 5B
4 Pn1
3 BP2
7 AB1
STP
RR+
B–R
1 5M
(IG)
34
B W W
3 Pn1
2 BP2
RR–
10A
MET IGN
W–B
6
B–R
A25
IG+
Junction ABS
13
39
Connector B–R B–R
WA
1
5
1
6 HB1
B
LP
(∗2, ∗3)
HIACE (EM04Z2E)
2
A9
Brake Vacuum Brake
Warning SW
18
37
B B
B
38 HB1
PKB
(∗7)
(∗2, ∗3)
2
1
W–B B
PKBI
A1
(∗2, ∗3)
36
A10 B B B
17 5B
2 5D
Brake Fluid (∗1) (∗7) (∗7)
SW
Level Warning SW
H20
1
2
4
13
12
B B B B B Combination Meter
2 5C
56 HB1
(∗7) (∗8) (∗8)
B3 B34
3
1
Parking Junction B B
Brake SW Connector (∗8) (∗8)
H48
Junction
Connector
221
ABS
: Parts Location
48 (LHD) 54 (*5) 44 (*1)
A9 B18
58 (RHD) 56 (*6) 45 (*2)
48 (LHD) 44 (*1) 46 (*3)
A10 B36
58 (RHD) 45 (*2) 52 (*4)
48 (LHD) 46 (*3) 54 (*5)
A24 B19
58 (RHD) 52 (*4) 56 (*6)
48 (LHD) 54 (*5) 49 (LHD)
A25 H20
58 (RHD) 56 (*6) 59 (RHD)
48 (LHD) 44 (*1) 49 (LHD)
B2 H23
58 (RHD) 45 (*2) 59 (RHD)
48 (LHD) 46 (*3) H48 59 (RHD)
B3 B20
58 (RHD) 52 (*4) 51 (LHD)
n1
44 (*1) 54 (*5) 61 (RHD)
45 (*2) 56 (*6) 51 (LHD)
B18 n2
46 (*3) 48 (LHD) 61 (RHD)
B34
52 (*4) 58 (RHD)
: Relay Blocks

5C
5D
30
5H
5J
5M
31
5S
6C

66 (LHD)
74 (RHD)
68 (LHD)
76 (RHD)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
68 (LHD)
Pn1 Frame Wire and Skid Control Sensor Wire (Under the Floor Panel)
76 (RHD)
: Ground Points
66 (LHD)
A1 Dash Panel Right
74 (RHD)
66 (LHD)
A2 Dash Panel Left
74 (RHD)
222
HIACE (EM04Z2E)
SRS
NOTICE : When inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions
and the procedure, and precautions in the Repair Manual applicable for the model year.
● Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most important source of information
when troubleshooting. When troubleshooting the SRS, always inspect the DTCs before disconnecting the battery.
● Work must be started more than 90 seconds after the ignition SW is turned to the ”LOCK” position and the negative
(-) terminal cable is disconnected from the battery.
(The SRS is equipped with a back-up power source so that if work is started within 90 seconds from disconnecting
the negative (-) terminal cable of the battery, the SRS may deploy.)
● When the negative (-) terminal cable is disconnected from the battery, the memory of the clock and audio system will be
cleared. So before starting work, make a record of the contents in the audio memory system. When work is finished, reset
the audio systems as they were before and adjust the clock. Some vehicles have power tilt steering, power telescopic
steering, power seat and power outside rear view mirror which are all equipped with memory function. However, it is not
possible to make a record of these memory contents. So when the work is finished, it will be necessary to explain it to your
customer, and ask the customer to adjust the features and reset the memory. To avoid erasing the memory in each system,
never use a back-up power supply from outside the vehicle.
● Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair.
● Do not expose the following parts directly to hot air or flame;
● Even in cases of a minor collision where the SRS does not deploy, the following parts should be inspected;
● Never use SRS parts from another vehicle. When replacing parts, replace with new parts.
● For the purpose of reuse, never disassemble and repair the following parts.
● If the following parts have been dropped, or have cracks, dents and other defects in their case, bracket, and connector,
replace with new one.
● Use a volt/ohmmeter with high impedance (10 kΩ/V minimum) for troubleshooting electrical circuits of the system.
● Information labels are attached to the periphery of the SRS components. Follow the instructions of the notice.
● After work on the SRS is completed, check the SRS warning light.
● If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the Repair Manual.
* Steering wheel pad

* Front passenger airbag assembly
* Seat belt pretensioner
* Center airbag sensor assembly
* Front airbag sensor assembly
223
HIACE (EM04Z2E)
SRS
∗ 1 : w/ Front Passenger' s Airbag
(IG) (IG) ∗ 2 : w/ Engine Immobiliser System
15A 10A
IGN MET IGN
1 5M
16 5E
B–R
B–O
6
IG+
B–Y
SRS
Combination Meter
14 5S
H20
SW
32 5E 40
B–Y
B–O
B–Y
21 A 14 A
IG2 LA
B4(A), B5(B), B6(C)
Airbag Sensor Assembly Center
D+ D– P+ P– +SL –SL +SR –SR PD+ PD–
5 A 6 A 4 A 3 A 30 A 28 A 29 A 27 A 2 B 1 B
BR–W
W–R
B–W
Y–G
Y–R
Y–B
Y–B
(∗1)
(∗1)
BR
Y
1 HB3 3 HB3 2 HB3 4 HB3 2 AB2 4 AB2 1 AB2 3 AB2

BR–W
W–R
B–W
Y–G
Y–R
(∗1)
(∗1)
BR
1 A 2 A (LHD)
2 1 2 1 1 B 2 B (RHD)
Y–B
2 HJ1 1 HJ1 +SL –SL +SR –SR L+(LHD) L–(LHD)

R+(RHD) R–(RHD)
Pretensioner
1 2 A13 A12 B23(A)
Y–B
(∗1)
(∗1)
Y
D+ D– Airbag Sensor Airbag Sensor Front Seat Outer Belt (LH)

(Front LH) (Front RH) B25(B)
Front Seat Outer Belt (RH)
Spiral
Cable
1 2
P+ P–
H32 J1
Airbag Squib Airbag Squib
(Steering Wheel Pad) (Front Passenger' s
Airbag Assembly)
224
HIACE (EM04Z2E)
Engine ECU
B7(B)
DLC3
H23
F/PS TC SIL
32 B 13 7
W
(∗2)
17 6C
(2TR–FE)
L
P–B
(∗3)
W 18 6C
W
8 5E (∗2)
4 5H 3 5S
15 5E
13 5E 31 5E
(2TR–FE)
L
P–B
22 A 15 A 16 A
GSW2 TC SIL
B4(A), B5(B), B6(C)
Airbag Sensor Assembly Center
PP+ PP– E1 E2
4 C 5 C 25 A 26 A
W–B
W–B
Y–B
(∗1)
(∗1)
Y
14 5E 30 5E
1 A 2 A (LHD)
1 B 2 B (RHD) 12 5E 7 5M
R+(LHD) R–(LHD)
L+(RHD) L–(RHD)
W–B
Pretensioner
B25(A) 12
H41
Front Seat Outer Belt (RH) Junction
B23(B) Connector
Front Seat Outer Belt (LH)
1
W–B
W–B
B3 H1
225
HIACE (EM04Z2E)
SRS
: Parts Location
48 (LHD) B6 C 58 (RHD) 49 (LHD)
A12 H23
58 (RHD) 44 (*1) 59 (RHD)
B7 B
48 (LHD) 52 (*4) 49 (LHD)
A13 H32
58 (RHD) A 50 (LHD) 59 (RHD)
B23
48 (LHD) B 60 (RHD) 49 (LHD)
B4 A H41
58 (RHD) A 50 (LHD) 59 (RHD)
B25
48 (LHD) B 60 (RHD) 48 (LHD)
B5 B J1
58 (RHD) 49 (LHD) 58 (RHD)
H20
B6 C 48 (LHD) 59 (RHD)

5H 30
31
5S
6C

66 (LHD) Cowl to Head Lamp Wire and Engine Room Main Wire (RH Side of Instrument Panel R/B)
AB2
74 (RHD) Cowl to Head Lamp Wire and Engine Room Main Wire (Near the Parking Brake SW)
66 (LHD)
74 (RHD)
66 (LHD)
HJ1 Instrument Panel Wire and Instrument Panel No.3 Wire (Upper Side of Glove Box)
74 (RHD)
: Ground Points
62 (*1)
63 (*2)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
66 (LHD)
74 (RHD)
226
HIACE (EM04Z2E)
Memo
227
HIACE (EM04Z2E)
Shift Lock
(ACC) (IG) (BAT)
7. 5A 7. 5A 10A
ACC ECU–IG STOP
4 5S 7 5S 18 5S 4 5J 3 5J
G–W
R–W
G–B
B–R
GR
17 HB4
5 6B 1 6A
G–B
7 6B 3 6A
2
Stop Lamp SW
G–W
B–R
GR
B2
1
6 1 7
R–W
ACC IG STP
19 HB4
KLS+ E P E SLS– SLS+
R–W
12 8 H22
W–B
L–W
Shift Lock Solenoid

P
4
Solenoid
H26
Interlock
W–B
Unlock
Key
Warning SW
3 13 6F 10 6F 9 6F
15 6F 1 6F
W–B
W–B
W–B
H2
228
HIACE (EM04Z2E)
: Parts Location
48 (LHD) 49 (LHD) 49 (LHD)
B2 H22 H26
58 (RHD) 59 (RHD) 59 (RHD)

5J 30
5S 31
6A
6B
6F

66 (LHD)
74 (RHD)
: Ground Points
66 (LHD)
74 (RHD)
229
HIACE (EM04Z2E)
Key Reminder and Light Reminder
(BAT) (IG) (BAT)

120A ∗ 3 : Before Oct. 2006 Production, 10A 10A
MAIN4 RHD From Oct. 2006 Production MET IGN DOME
RHD From Apr. 2009 Production 2
1 1G 1 5M 2
R
B–G
G
18 5E
B–R
1 5G 6 5Q
8 5S
G
10A PANEL
R
10 6 5
Relay
T–LP
ILL+ IG+ B
Buzzer
9 5S
KSW E1 SW
R–G
11 H20 7 12
Combination Meter
Y
R–G
2 9 5D
H42
Junction
15 6D
W–B
Connector
(∗3)
1
14 5H
Y
R–G
(∗1) 13 6D
(∗2)
Y
1 6B 11 6C 1 HH1
14 A (LHD)
R–G
15 B (RHD)
A H T EL
2 6B 3 6B 12 6C 13 6C 7 5D
OFF
W–B
W–B
(∗4)
(∗3)
(M/T ∗1)
(M/T ∗2)
(A/T ∗1)
(A/T ∗2)
Control SW
Y–B
Y–B
Tail
Y
Y
Light
Head
27 5E
AUTO
H28(A), H29(B) 16 A (LHD) 2 2

Warning SW
Warning SW
(RHD)
W–B
(LHD)
Unlock
Unlock
W–B
R–G
R–L
H26
H27
1 1
7 6F 9 6F
Door Courtesy SW
Door Courtesy SW
(M/T)
(A/T)
W–B
W–B
1 1
(Front RH)
(Front LH)
10 6F 16 6F 17 6F
B22
B26
1 6F
W–B
H2
230
HIACE (EM04Z2E)
: Parts Location
B22 50 (LHD) 49 (LHD) H28 A 49 (LHD)
H26
B26 60 (RHD) 59 (RHD) H29 B 59 (RHD)
49 (LHD) 49 (LHD) 49 (LHD)
H20 H27 H42
59 (RHD) 59 (RHD) 59 (RHD)
: Relay Blocks

5E
5G
5H 30
5M
5Q 31
5S
6B
6C
6D
6F

HH1
: Ground Points
66 (LHD)
74 (RHD)
231
HIACE (EM04Z2E)
Seat Belt Warning
(IG) (IG)
10A 10A
∗ 1 : Before Oct. 2006 Production, MET IGN GAUGE
RHD From Oct. 2006 Production
∗ 3 : RHD Before Sep. 2007 Production
1 5M 1 5P
(RHD)
L–R
∗ 6 : RHD From Apr. 2009 Production
7
Clearance Warning
B–R
BD
Front Passenger' s
Seat Belt Warning
Light
Indicator
H15
DOSW
8
B–R
(∗5)
R–B
H20 (∗6)
Combination Meter 6 28
IG+ PBLT
Seat Belt
Driver' s
Buzzer
(∗3)
W
E1 L P/SB
7 19 34
W
(∗4)
LG
7 HB1
2 HB2
(RHD)
W
W–B
(∗1)
(LHD)
2 RB1
LG
1 HH1
(RHD)
W
(RHD)
2 RB1 2
LG
(LHD)
W
Front Seat Inner Belt

W–B
W–B
(∗1)
(∗2)
Occupant
Detection
2 2
Sensor
(Driver' s Side)
(Driver' s Side)
B11
R2
1 1 1 R1
(LHD)
W–B
(Front Passenger' s Side)

W–B
(RHD)
(RHD)
1 RB1
W–B
W–B
(LHD)
(RHD)
W–B
W–B
H2 B2 B3
232
HIACE (EM04Z2E)
: Parts Location
52 (*4) H15 59 (RHD) R1 60 (RHD)
B11 54 (*5) 49 (LHD) R2 50 (LHD)
H20
56 (*6) 59 (RHD)

5M
5P

HB1 74 (RHD)
66 (LHD) Instrument Panel Wire and Engine Room Main Wire (Near the Steering Column)
HB2
74 (RHD)
HH1
68 (LHD)
RB1 Seat No.2 Wire and Engine Room Main Wire (Center Pillar LH)
76 (RHD)
: Ground Points
62 (*1)
63 (*2)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
70 (*4)
72 (*6)
66 (LHD)
74 (RHD)
233
HIACE (EM04Z2E)
Remote Control Mirror
(ACC)
7. 5A
ACC
6 5S
GR
GR
1
I14
Junction
Connector
13 IH3 (LHD) 4
13 IH4 (RHD)
GR
I8
Outer Mirror SW 8
B
Operation SW
Left Right Up Down Left/ Right/
Up Down
Retract SW
MH MV
Select SW
Left Right Left Right
MH MV MLH MRH MLV MRV M+ E

10 9 5 2 4 3 6 7
(RHD)
(RHD)
LG–B
R–W
R–Y
W
G
B
W–B
14 IH4 5 IH4 2 IH1 10 IH1 1 IH1 9 IH1 17 IH1 (LHD)
7 IH4 6 IH4 16 IH4 15 IH4 8 IH4 (RHD)
R–W
R–Y
I12(A), I13(B)
8 B
Connector
Junction
(RHD)
(RHD)
W
LG–B
30 HA1
R–Y
B
7 A
29 HA1 5 HA1 32 HA1 9 HA1 33 HA1 18 HA1
G
G
W–B
(RHD)
(RHD)
LG–B
R–W
R–Y
W
G
G
B
17 IH3 (LHD)
17 IH4 (RHD)
4 LA2 3 LA2 8 LA2 4 KA2 3 KA2 8 KA2
R–W
W
G
R
Y
2 3 1 2 3 1
W–B
MH MV M+ MH MV M+
13
Connector
Junction
H41
MR MF MR MF
5 4 L3 5 4 K3 1
(RHD)
(RHD)
(RHD)
(RHD)
Outer Rear Outer Rear

B
B
L
View Mirror (LH) View Mirror (RH)
1 LA2 5 LA2 1 KA2 5 KA2

W–B
(RHD)
(RHD)
(RHD)
(RHD)
B
B
L
L L
(RHD) (RHD)
B B H1
(RHD) (RHD)
234
HIACE (EM04Z2E)
: Parts Location
49 (LHD) I12 A 57 (RHD) 50 (LHD)
H41 K3
59 (RHD) 49 (LHD) 60 (RHD)
I13 B
49 (LHD) 57 (RHD) 50 (LHD)
I8 L3
57 (RHD) 49 (LHD) 60 (RHD)
I14
I12 A 49 (LHD) 57 (RHD)


66 (LHD)
74 (RHD)
IH3 66 (LHD)
IH4 74 (RHD)
67 (LHD)
KA2 Front Door RH Wire and Cowl to Head Lamp Wire (Right Kick Panel)
75 (RHD)
67 (LHD)
LA2 Front Door LH Wire and Cowl to Head Lamp Wire (Left Kick Panel)
75 (RHD)
: Ground Points
66 (LHD)
74 (RHD)
235
HIACE (EM04Z2E)
Cigarette Lighter
(ACC)
15A
CIG
3 5Q
R–W
1
H12
Cigarette
Lighter
2
W–B
4
H41
Junction
Connector
1
W–B
H1
236
HIACE (EM04Z2E)
: Parts Location
49 (LHD) 49 (LHD)
H12 H41
59 (RHD) 59 (RHD)

: Ground Points
66 (LHD)
74 (RHD)
237
HIACE (EM04Z2E)
Horn
(BAT)
15A
HAZ–HORN
HORN
Relay
7 1I 8 1I
Y
8 HB4 18 AB1
Y
15 5C
12 5H 1 1
A15 A16
Horn Horn
(Low) (High)
Y
HO
Horn SW
Spiral Cable
H31
238
HIACE (EM04Z2E)
: Parts Location
48 (LHD) 48 (LHD) 49 (LHD)
A15 A16 H31
58 (RHD) 58 (RHD) 59 (RHD)

1I 25 Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
5C
5H

66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
239
HIACE (EM04Z2E)
Rear Window Defogger
(BAT) (IG)
30A 10A
DEF GAUGE
DEF
Relay
2 5F 12 5Q 4 5Q
10A
P–B
ELS
B
L–R
5 HB2
11 5M
(2TR–FE)
B
L–R
7 BT2
P–B
L–R
1 A
Rear Window
27 HB1
b1(A), b2(B)
Defogger
2 3
L
D IG
1 B
(2TR–FE)
L–R
Defogger SW
Rear Window
B
8 dT1
Timer
H17
1 db2 E
3 B 1 Off
ELS3
L
On
B
W–B
B7(B)
Engine ECU 1 db1 1 dT1
6
H41
Junction
B
W–B
Connector
1
3 TY1
W–B
W–B
Y1 H1
240
HIACE (EM04Z2E)
: Parts Location
44 (*1) 49 (LHD) 51 (LHD)
H17 b1 A
45 (*2) 59 (RHD) 61 (RHD)
B7 B
52 (*4) 49 (LHD) 51 (LHD)
H41 b2 B
54 (*5) 59 (RHD) 61 (RHD)

5F 30
31
5Q

66 (LHD)
74 (RHD)
66 (LHD)
HB1
74 (RHD)
66 (LHD)
HB2
74 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
db1 Back Door No.3 Wire and Rear Window No.1 Wire (Near the Center Stop Lamp)
76 (RHD)
68 (LHD)
db2 Back Door No.3 Wire and Rear Window No.1 Wire (Near the Rear Wiper Motor)
76 (RHD)
: Ground Points
66 (LHD)
74 (RHD)
68 (LHD)
76 (RHD)
241
HIACE (EM04Z2E)
Parking Assist (TOYOTA Parking Assist-Sensor)
(BAT)
120A
MAIN4
1 1G
H15
Clearance Warning Indicator
B–G
1 5G
E SK BZ OP
1 12 11 10
10A PANEL
Relay
T–LP
W–B
L–W
L–R
L
8 10 30
IG CBZ L10
9 5S 7 5P
H33
Clearance Warning ECU
TL E S1 E1
R–G
26 27 1 14
G
G
R
24 HA1 39 HA1
W–B
2 5
H42 H41
Junction Junction
Connector Connector
G
R
1 1
W–B
R–G
20 6F
14 A (LHD) 1 CA1 4 CA1
15 B (RHD)
H T EL A
G
R
10 6F
OFF
Control SW
W–B
Tail
Light
Head
Ultrasonic Sensor No. 1
Auto
9 6F
H28(A), H29(B) 16 A (LHD) 2
Combination SW 9 B (RHD) S
(Front RH)
W–B
7 6F 1 6F E
C3
1
W–B
W–B
W–B
H1 H2
242
HIACE (EM04Z2E)
H15
Clearance Warning Indicator
L–R
BK FL RL FR RR BD
9 5 4 3 2 7
P–L
Y–G
Y–R
Y–B
L–R
L–B
Y
P–L
11 31 12 32 13 25
L7 L4 L6 L1 L5 SPD
H33
S4 E4 S5 E5 S6 E6 S7 E7 S8 E8 PL RL
2 15 3 16 4 17 5 18 6 19 28 9
(A/T)
R–W
W
R
B
Y
L
L
23 HA1 38 HA1 2 HB4 13 HB4 5 HB4 16 HB4 4 HB4 15 HB4 3 HB4 14 HB4
W
R
B
Y
L
4 BP3 9 BP3 1 BP3 6 BP3 3 BP3 8 BP3 2 BP3 7 BP3

W
B
W
R
B
Y
L
3 CA1 6 CA1 1 SP1 5 SP1 4 SP1 8 SP1 2 SP1 6 SP1 3 SP1 7 SP1
W
W
R
B
Y
L
1 WS1 5 WS1 4 WS1 8 WS1 2 WS1 6 WS1 3 WS1 7 WS1

GR
W
R
B
Y

L
2 2 2 2 2
S S S S S
(Front LH)
(Rear RH)
(Rear LH)
(RH)
(LH)
E E E E E
W4
W1
W3
W2
C1
L
1 1 1 1 1
R–W
(A/T)
243
HIACE (EM04Z2E)
(IG) (BAT)
10A 10A
GAUGE DOME
2
1 5P 2 5E 2
L–R
L–R
R
L–R
5 DB4
P–L
L–R
L–R
(A/T)
L–R
(M/T)
P–L
(A/T)
L–R
18 5E
(M/T)
L–R
11
Connector
Junction
Back–Up Lamp SW
L–R
H42
2
RL RB PL
8 8 5S
D36 P
P–L
D37
1
1 (M/T) 1 6
IG+
L
Speed Sensor
(A/T)
R–W
R
(A/T)
H20
D38
E SI 5 Combination Meter 8 DB5

2 3 B 1 DB4
P–L
Speedometer
(A/T)
R–W
BR
13 5H 7 DB4 3 DB4
1 5E 48 HB1
BR
(A/T)
R–W
14 5D SI E3 +S E1
22 HB1 58 HB1 15 29 9 7 11 5D
1 6D
L
P–L
BR
P
P–L
BR
W–B
P
(∗2)
15
Connector
Junction
H42
4 6D
18
1 HH1
(A/T)
R–W
W–B
W–B
(∗2)
(∗3)
R–W
(A/T)
H2
244
HIACE (EM04Z2E)
: Parts Location
48 (LHD) 49 (LHD) 49 (LHD)
C1 H15 H42
58 (RHD) 59 (RHD) 59 (RHD)
48 (LHD) 49 (LHD) 51 (LHD)
C3 H20 W1
58 (RHD) 59 (RHD) 61 (RHD)
44 (*1) H28 A 49 (LHD) 51 (LHD)
D36 W2
52 (*4) H29 B 59 (RHD) 61 (RHD)
44 (*1) 49 (LHD) 51 (LHD)
D37 H33 W3
52 (*4) 59 (RHD) 61 (RHD)
44 (*1) 49 (LHD) 51 (LHD)
D38 H41 W4
52 (*4) 59 (RHD) 61 (RHD)
: Relay Blocks

5E
5G
5H 30
5P Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
31
5S
6D
6F

68 (LHD)
76 (RHD)
66 (LHD)
74 (RHD)
62 (*1)
DB4
70 (*4)
62 (*1)
DB5
70 (*4)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
HH1
68 (LHD)
SP1 Frame No.3 Wire and Frame Wire (Under the Floor Panel)
76 (RHD)
68 (LHD)
WS1 Luggage Room Wire and Frame No.3 Wire (Inside of Rear Bumper LH Side)
76 (RHD)
245
HIACE (EM04Z2E)
: Ground Points
66 (LHD)
H1
74 (RHD)
66 (LHD)
H2
74 (RHD)
246
HIACE (EM04Z2E)
Memo
247
HIACE (EM04Z2E)
Audio System
∗ 1 : 4 Speaker
(BAT) (ACC) ∗ 2 : 6 Speaker
∗ 4 : Except ∗3
15A 7. 5A ∗ 5 : w/ Radio Data System
RADIO ACC
L2 K2
2
Speaker Speaker
(Front Door LH) (Front Door RH)
2 6 5S 1 2 1 2
L–Y
GR
W
R
L
3 HB1
4 LA3 8 LA3 4 KA3 8 KA3
L–Y
GR
LG
P
L
6 IH1 13 IH3 (LHD) 8 HA2 13 HA2 12 HA2 15 HA2
13 IH4 (RHD)
L–Y
GR
LG
P
L
1 1
Connector
Connector
Junction
Junction
3 3 13 IH1 14 IH1 15 IH1 5 IH1

I11
I14
2 2
LG
P
L
L–Y
L–Y
(∗5)
(∗5)
GR
GR
8 D 4 A 18 D 3 A 2 A 6 A 1 A 5 A
+B B ACC ACC FL+ FL– FR+ FR–
I1(B), I2(A), I17(C), I18(D)
TX3– GND GND1 RL+ RL– TX– TX– RR+ RR– TX+ TX+
10 D 7 A 4 D 2 B 6 B 9 C 11 D 1 B 3 B 10 C 3 D
W–B
(∗5)
(∗5)
BR
BR
W
R
B
W B
(∗5) (∗5)
4 IH1 12 IH1 3 IH1 11 IH1
W
R
B
43 HB1 5 HB1 42 HB1 4 HB1

BR
W
R
B
Y
I12(A), I13(B)
12 B
Connector
5 BT2 6 BT2 9 BT2 10 BT2

Junction
7 A
W–B
(∗5)
(∗1)
(∗1)
W
R
B
17 IH4 2 IH3 (LHD) 6 TY1 5 TY1 9 TU3 8 TU3 (∗3)

2 IH4 (RHD) 9 TU2 8 TU2 (∗4)
W–B
(∗5)
(∗2)
(∗2)
(∗2)
(∗2)
W
W
R
P
13
Connector
1 UX1 2 UX1
Junction
BR
Y
H41
W
R
1
1 2 1 2 1 2 1 2
W–B
(∗5)
Y1 T10 X1 T11
Speaker Speaker Speaker Speaker
H1 H2 (Rear LH) (Roof LH) (Rear RH) (Roof RH)
248
HIACE (EM04Z2E)
: Parts Location
H41 59 (RHD) 49 (LHD) L2 60 (RHD)
I13 B
49 (LHD) 57 (RHD) T10 50 (LHD)
I1 B
57 (RHD) 49 (LHD) T11 50 (LHD)
I14
49 (LHD) 57 (RHD) 51 (LHD)
I2 A X1
57 (RHD) I17 C 57 (RHD) 61 (RHD)
49 (LHD) I18 D 57 (RHD) 51 (LHD)
I11 Y1
57 (RHD) 50 (LHD) 61 (RHD)
K2
49 (LHD) 60 (RHD)
I12 A
57 (RHD) L2 50 (LHD)
: Relay Blocks


66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
IH3 66 (LHD)
IH4 74 (RHD)
67 (LHD)
KA3 Front Door RH Wire and Cowl to Head Lamp Wire (Right Kick Panel)
75 (RHD)
67 (LHD)
LA3 Front Door LH Wire and Cowl to Head Lamp Wire (Left Kick Panel)
75 (RHD)
68 (LHD)
TU2
76 (RHD)
68 (LHD)
TU3
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
: Ground Points
H1 74 (RHD)
H2
74 (RHD)
249
HIACE (EM04Z2E)
Combination Meter and Clock
(IG) (BAT)
10A 10A
GAUGE DOME ∗ 1 : 2TR–FE
∗ 3 : 5L–E
2 ∗ 4 : Optitron Meter (Before Oct. 2006 Production)
∗ 5 : 1KD–FTV A/T, 2KD–FTV A/T
∗ 6 : w/o ABS
2 5E 2
∗11 : 1KD–FTV
R
L–R
∗12 : 2KD–FTV
∗16 : w/ Front Passenger' s Seat Belt Warning From Sep. 2007 Production
18 5E
∗17 : w/ Front Passenger' s Seat Belt Warning From Apr. 2009 Production
8 5S
R
H20
5 Combination Meter
B
Illumination
Illumination
Speedometer
Pointer
Tachometer
Temp.
Fuel
Door
Clock /
ODO LCD
SW2 SW SI E3 L E2 +S
4 12 15 29 13 8 9
B35
Junction Connector
W–B
Y–R
P–L
BR
P
R–G
Y–R
4 5
58 HB1 22 HB1 20 HB1 44 HB1 14 5D
P–L
P–L
(∗7)
W–B
Y–R
L–R
BR
P
3 BP1 7 BP1
Door Courtesy SW (Front LH) (RHD)
Door Courtesy SW (Front RH) (LHD)
Door Courtesy SW (Front RH) (RHD)

Door Courtesy SW (Front LH) (LHD)
Door Courtesy SW (Slide Door LH)
Door Courtesy SW (Slide Door RH)
Back Door Courtesy SW
5 DB4 13 5H 24 5E
3 DB4 7 DB4
W–B
Y–R
P–L
2 Ph1 4 Ph1
L–R
Fuel Suction Pump and Gage Assembly
8
Connector
2 Bq2
BR
Junction
P
W–B
Y–R
H42
3 2
11 9
SI E 2 A (∗2, ∗3)
2 B (∗1)
P–L
P–L
P–L
(∗7)
Fuel Sender Gage
IG+
Gage
Door Control Relay

(Power Slide Door)
D38 25 36 26 B
1
Warning ECU
Speed
A/C Amplifier
SPD SPD SPD

h1(A)
h2(B)
Sensor
Clearance
L–R
3 A (∗2, ∗3)
q4(B)
H33
H18
3 B (∗1)
250
HIACE (EM04Z2E)
O3(A)
1 1G
(BAT)
6
P–L P–L P–L
25 A
4 DB2
B–G
120A MAIN4
SPD1
(∗5) (∗5) (∗5)
Buzzer
2 DO1 (∗12)
2 DO2 (∗11)
B–G
B7(B), B8(F), B9(A), B10(E) R–G
9 5S
1 5G
Engine ECU
Combination SW
7
P–L P–L
9 E
17 B
8 B
SPD
B35 T–LP
Junction Relay
Connector
14
B–Y B–Y B–Y
7 F
4 A
1 B
16 6C
14 6C
10
18 HB1
G
TACH
6 5Q
ILL+
17
Y Y Y 10A PANEL
57 HB1
S
THWO
8 E (∗3)
2 A (∗2)
14 B (∗1)
34
R R Park/Neutral
34 HB1
(∗4) (∗4) Position SW
12
15
W–B W–B W–B
Clock SW
B2
(∗2, ∗3) (∗2, ∗3) ST(∗4)
B36 P/SB(∗16) W Front Seat Inner Belt
Junction (∗16) (Front Passenger' s Side)
Connector
ODO TRIP SW
28
B–R
W–B
B21 (∗16)
Fuel Sedimentary Clearance Warning
PBLT
W–B
(∗2, ∗3)
Level Warning SW Indicator
Oil Level
2
1
16
R–B R–B R–B
37 HB1
L
(∗2, ∗3) (∗2, ∗3) (∗17)
HIACE (EM04Z2E)
H20
T–Belt
11
Y
Unlock Warning SW
KSW
8
DB4
Filter
Combination Meter
19
Front Seat Inner Belt LG
L
(Driver' s Side)
D11(A), D12(B)
W–B
Engine Oil Fuel
Level Sensor
20
Y–G Y–G Y–G
4 DB4
19 HB1
OIL
Driver' s
2 A (∗1)
1 A (∗1)
Seat Belt
6
B–R
2 B (∗2, ∗3)
1 B (∗2, ∗3)
1 5M
(IG)
IG+
2
1
18
W–B W–B LG LG
Tail
10A
B3
6 HB2
S
(∗2, ∗3) (∗2, ∗3) (∗2, ∗3)

MET IGN
B30
Fuel Filter
(∗6)
W–B
Warning SW
251
∗ 1
: 2TR–FE
∗ 2
: 1KD–FTV, 2KD–FTV
∗ 3
: 5L–E
∗ 6
: w/o ABS
∗ 8
: w/ ABS
∗ 9
: Before Oct. 2006 Production, RHD From Oct. 2006 Production
∗10 : LHD From Oct. 2006 Production, RHD From Apr. 2009 Production
∗14 : Except ∗15
∗15 : RHD From Sep. 2007 Production
H20
Combination Meter
Check Engine
Charge
Brake
Glow
SRS
ABS
LP CHG– PKBI SW L EGW SW

39 33 37 36 25 32 40
B–W
G–R
B–Y
B
56 HB1 A25
B
Junction
B–R
Connector
(∗1)
B
1 2 12
Connector
(∗15 ∗8)
(∗15 ∗8)
Junction
Assembly Center
Engine ECU
Engine ECU
Alternator
B34
Airbag Sensor
5
(∗8 ∗14)
(∗2, ∗3)
(∗2, ∗3)
13
B
1 3
Connector
6 HB1
Junction
B
H48
4 2
Level Warning SW
1 1 1
Brake Vacuum
(∗8 ∗14)
(∗8 ∗14)
(∗2, ∗3)
B(∗1)
+
Warning SW
(∗15 ∗8)
(∗15 ∗8)
Brake Fluid
B
Brake SW
B
Parking
W–B
(∗6)
E
A10
A9
B3
2
W–B
W–B 38 HB1 2 5D 2 5C 17 5B
(∗6)
B–R
(∗8)
(∗8)
B
Skid Control ECU

with Actuator A1
252
HIACE (EM04Z2E)
Oil Pressure
27
W W W
2 DB4
35 HB1
S
1 B (∗3)
1 A (∗1, ∗2)
Security
Engine Oil
35
R
Transponder Key ECU
D7(A), D8(B)
Pressure SW
(∗13)
LP
P
24
R–W
P
R
23
L Park/Neutral
Position SW
R
N
22
GR
H20
D
21 G–Y
D
Combination Meter
3
1
B
3
2
2
Y
2
Park/Neutral
HIACE (EM04Z2E)
Position SW
L
3
R
L
High Beam
38
R–B
Headlamp (LH), (RH)
+
Turn LH
31
L
B
Flasher Relay
Turn RH
26
L–R
W–B
B
(∗10)
Front Fog
7
30
W–B W–B Y
FR FOG Relay
H2
1 HH1
(∗9) (∗9)
E1
FOG
253
: Parts Location
48 (LHD) 54 (*5) 54 (*5)
A9 B30 D12 B
58 (RHD) 56 (*6) 56 (*6)
48 (LHD) 48 (LHD) 44 (*1)
A10 B34
58 (RHD) 58 (RHD) 45 (*2)
48 (LHD) 44 (*1) 46 (*3)
A25 D38
58 (RHD) 45 (*2) 52 (*4)
48 (LHD) 46 (*3) 55 (*5)
B3 B35
58 (RHD) 52 (*4) 56 (*6)
44 (*1) 54 (*5) 49 (LHD)
H18
45 (*2) 56 (*6) 59 (RHD)
B7 B
52 (*4) 45 (*2) 49 (LHD)
H20
54 (*5) 46 (*3) 59 (RHD)
B36
46 (*3) 54 (*5) 49 (LHD)
B8 F H33
56 (*6) 56 (*6) 59 (RHD)
45 (*2) 44 (*1) 49 (LHD)
B9 A H42
54 (*5) 45 (*2) 59 (RHD)
D7 A
46 (*3) 52 (*4) H48 59 (RHD)
B10 E
56 (*6) 54 (*5) 48 (LHD)
O3 A
45 (*2) 46 (*3) 58 (RHD)
D8 B
46 (*3) 56 (*6) 51 (LHD)
B21 h1 A
54 (*5) 44 (*1) 61 (RHD)
D11 A
56 (*6) 52 (*4) 51 (LHD)
h2 B
45 (*2) 45 (*2) 61 (RHD)
B30 D12 B
46 (*3) 46 (*3) q4 B 61 (RHD)
: Relay Blocks

5C
5D
5E
5G
5H 30
5M
5Q 31
5S
6C

68 (LHD)
76 (RHD)
63 (*2)
DB2
71 (*5)
DB4 63 (*2)
64 (*3)
254
HIACE (EM04Z2E)
70 (*4)
DB4 71 (*5) Engine Wire and Engine Room Main Wire (Front Side of Engine Room R/B No.1)
72 (*6)
63 (*2)
DO1
DO2 71 (*5)
66 (LHD)
HB1
74 (RHD)
66 (LHD)
HB2
74 (RHD)
HH1
68 (LHD)
76 (RHD)
: Ground Points
66 (LHD)
A1 Dash Panel Right
74 (RHD)
62 (*1)
63 (*2)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
62 (*1)
63 (*2)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
66 (LHD)
74 (RHD)
255
HIACE (EM04Z2E)
Cooling Fan (2TR-FE, 1KD-FTV, 2KD-FTV)
(IG) (BAT) (BAT) (BAT)
10A 50A 50A 30A

GAUGE FAN1 FAN2 FAN3
9 5C 4 1C 4 1B 3 1C
B–R
R–B
L–R
(∗2)
B
59 HB1
L–R
3
LG–B
7 DB2
Junction Connector
(∗2)
10 L–R
(∗2)
LG–B
9 L–R (∗1)
B36
P–L
LG–B
(∗1)
8
(∗2)
Connector
Junction
LG–B 5
B36
(∗1)
R–B
L–R
(∗2)
(∗2)
B–R
L–R
L–R
6
B
1 1 1 1 1 1I 2 1I
1 3 1 3
LG–B
LG–B
FAN1 FAN2 FAN3
P–L
(∗2)
(∗1)
(∗2)
Relay Relay Relay
2 5 2 5
1 1 1 1 4 1I 3 1I
W–B
W–B
(∗2)
R
B–W
5 AB1 W–L
(∗2)
1 A 2 A 1 A 2 A
B27(A), m1(B)
B28(A), m2(B)
+B1 SI +B2 SI2

(∗2)
Cooling Fan
Cooling Fan
R
ECU No. 1
ECU No. 2
Cooling Fan Motor
M+ M– E1 M+ M– E2
2
2 B 1 B 3 A 2 B 1 B 3 A
No. 2
M
W
W
R
A22
W–B
M M 1
W–B
m1(B) m2(B)
(∗2)
Cooling Fan Motor No. 1 Cooling Fan Motor No. 1

W–B
4
Connector
Junction
W–B
W–B
A25
W–B
3
W–B W–B W–B

W–B
W–B
(∗2)
B2 B1 B3 A1
256
HIACE (EM04Z2E)
∗ 1 : 2TR–FE
H18
∗ 3 : 1KD–FTV A/C Amplifier
16 DB1
∗ 4 : 2KD–FTV
∗ 5 : Shielded
Y–R
Y–R
∗ 6 : LHD 2TR–FE
CANH CANL SG–1 PRE S5 PS

10 11 12 4 13 21
Y–R
L–W
Y–R
R–L
(∗6)
W
V
L
Water Temp. Sensor
Water Temp. Sensor

1 1
Junction Connector
(Engine Coolant)
28 HA1 27 HA1 12 HA1
H3(A), H4(B)
1 A 2 A
(Radiator)
Y–R
Y–R
D32
B29
LG–B 1 B 2 B
2 2
(∗2) 10 6D
Y–R
Y–R
R–L
(∗6)
(∗6)
LG–B
V
(∗1)
11 6D
P–L 2 3 3 2
LG–B
Junction Connector
L–R
L–R
(∗2)
(∗2)
(∗1)
L–W
(∗2) PR + + PR
8
LG–B
W
B
(∗1)
D44
8 DB2 – –
2 17 DB1 11 HB4 22 HB4 36 HA1 (RHD) A4 1 A26 1
3 HA1 (LHD) A/C Pressure A/C Pressure
Sensor No. 1 Sensor No. 2
L–R
P–L
(∗2)
(∗1)
R–W
L–W
L–W
L–W
Y–R
(∗6)
W
B
10 A 32 D 28 D 31 C 33 B 34 B (∗1)
11 D 12 D 19 D 28 D 20 A 24 B 23 B (∗2)
RFC2 RFC THW E2 RTHW CANH CANL
B7(B), B9(A), D1(D), D3(C)
Engine ECU
FAN NE– NE+
34 D 27 D (∗1)
13 D 34 D 27 D (∗2)
W–L
(∗2)
(∗1)
17 DB1
B
4
Connector
Junction
W–L
D44
(∗2)
12
(∗1, ∗4)
(∗3)
(∗1)
(∗4)
(∗3)
(∗5)
G
Y
L
L
(∗5)
(∗2)
(∗5)
(∗1)
2 1
Position Sensor
NE– NE
Crankshaft
5 9
Connector
Connector
Junction
Junction
D43
D43
D17
G–
1 1 3
W–B
(∗2)
(∗1)
BR
B–R(∗1)
BR
(∗2)
D3 D2
257
HIACE (EM04Z2E)
Cooling Fan (2TR-FE, 1KD-FTV, 2KD-FTV)
: Parts Location
48 (LHD) 44 (*1) D32 55 (*5)
A4
58 (RHD) 45 (*2) 44 (*1)
B29
48 (LHD) 52 (*4) 45 (*2)
A22 D43
58 (RHD) 54 (*5) 52 (*4)
48 (LHD) 44 (*1) 55 (*5)
A25
58 (RHD) 45 (*2) 44 (*1)
B36
A26 48 (LHD) 52 (*4) 45 (*2)
D44
44 (*1) 54 (*5) 52 (*4)
45 (*2) 44 (*1) 55 (*5)
B7 B
52 (*4) 45 (*2) 42, 49 (LHD)
D1 D H3 A
54 (*5) 52 (*4) 42, 59 (RHD)
44 (*1) 54 (*5) 42, 49 (LHD)
H4 B
45 (*2) 44 (*1) 42, 59 (RHD)
B9 A
52 (*4) 45 (*2) 49 (LHD)
D3 C H18
54 (*5) 52 (*4) 59 (RHD)
44 (*1) 54 (*5) 44 (*1)
45 (*2) 44 (*1) 45 (*2)
B27 A m1 B
52 (*4) 45 (*2) 52 (*4)
D17
54 (*5) 52 (*4) 55 (*5)
44 (*1) 54 (*5) 44 (*1)
45 (*2) 44 (*1) 45 (*2)
B28 A m2 B
52 (*4) D32 45 (*2) 52 (*4)
54 (*5) 52 (*4) 55 (*5)
: Relay Blocks
22 (*7)
23 (*8)

1B
24
1C Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
1I 25
5C 30 Instrument Panel Wire and Instrument Panel J/B (Left Side of Instrument Panel)
6D

66 (LHD)
74 (RHD)
62 (*1)
63 (*2)
DB1
70 (*4)
71 (*5)
63 (*2)
DB2
71 (*5)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
258
HIACE (EM04Z2E)
: Ground Points
66 (LHD)
A1 Dash Panel Right
74 (RHD)
62 (*1)
63 (*2)
B1
70 (*4)
71 (*5)
Front Floor Panel Right
62 (*1)
63 (*2)
B2
70 (*4)
71 (*5)
62 (*1)
63 (*2)
70 (*4)
71 (*5)
62 (*1)
D2
70 (*4)
Engine Block
63 (*2)
D3
71 (*5)
259
HIACE (EM04Z2E)
Cooling Fan (5L-E)
(IG) (BAT) (BAT)
10A 50A 50A

GAUGE FAN1 FAN2
9 5C 4 1C 4 1B
B–R
L–R
59 HB1
L–R
7
Junction Connector
10 L–R L–R
LG–B
9 L–R
B36
B–R
L–R
8
L–R
1 1
1 1
1 3
1 3 FAN2
Relay
FAN1
Relay 2 5
2 5
LG–B
1 1
W–B
1 1
4
Connector
Junction
LG–B LG–B 5
W–B
B36
6
LG–B
B–W
1 A 2 A 1 A 2 A
B27(A), m1(B)
B28(A), m2(B)
+B1 SI +B2 SI2

Cooling Fan
Cooling Fan
ECU No. 1
ECU No. 2
M+ M– E1 M+ M– E2
2 B 1 B 3 A 2 B 1 B 3 A
W
W
R
R
W–B
M M
m1(B) m2(B)
Cooling Fan Cooling Fan Motor No. 1
W–B
Motor No. 1
W–B
W–B
W–B
W–B W–B W–B

W–B
B2 B1 B3
260
HIACE (EM04Z2E)
L–R
LG–B
3
4
1
2
W–B W–B R R R–B R–B
M
4 1I
1 1I
A1
3 1C
5 AB1
(BAT)
A25 A22
Junction Cooling Fan Motor No. 2 L–R
30A
3 1I
2 1I
Connector
FAN3
Relay
FAN3
W–L
LG–B
13 E
7 E
FAN
RFC
Engine ECU
3
2
W–B Y–G Y–G Y–G
8 G
A1
17 AB1
11 DB1
PR2
A5
Pressure SW
B8(F), B10(E), D2(H), D4(G)
1
6
BR (Shielded)
D4
1
2
D43 Y
19 H
NE+
Junction
Connector
D18
Engine Speed
Sensor
2
1
L L–R L–R Y–R Y–R
18 H
12 G
NE–
17 DB1
16 DB1
RTHW
HIACE (EM04Z2E)
B29
Water Temp. Sensor
(Radiator)
8
2
1
R–B R–B R–W Y–R

2 F
4 G
AC1
AC1
29 HB1
THW
D32
Water Temp. Sensor
(Engine Coolant)
10
G–W G–W Y–R
8 F
9 G
E2
51 HB1
ACT
ACT
3
4
1
R–L R–L R–B

27 5B
(IG)
28 HA1
PRE
A5
H19 Pressure SW
A/C
10A
A/C Amplifier
261
Cooling Fan (5L-E)
: Parts Location
48 (LHD) 46 (*3) 46 (*3)
A5 B28 A D32
58 (RHD) 56 (*6) 56 (*6)
48 (LHD) 46 (*3) 46 (*3)
A22 B29 D43
58 (RHD) 56 (*6) 56 (*6)
48 (LHD) 46 (*3) 49 (LHD)
A25 B36 H19
58 (RHD) 56 (*6) 59 (RHD)
46 (*3) 46 (*3) 46 (*3)
B8 F D2 H m1 B
56 (*6) 56 (*6) 56 (*6)
46 (*3) 46 (*3) 46 (*3)
B10 E D4 G m2 B
56 (*6) 56 (*6) 56 (*6)
46 (*3) 46 (*3)
B27 A D18
56 (*6) 56 (*6)
: Relay Blocks

1B
24
1C Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
1I 25

66 (LHD)
74 (RHD)
64 (*3)
72 (*6)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
: Ground Points
66 (LHD)
A1 Dash Panel Right
74 (RHD)
64 (*3)
B1
72 (*6)
64 (*3)
B2
72 (*6)
64 (*3)
72 (*6)
64 (*3)
D4 Engine Block
72 (*6)
262
HIACE (EM04Z2E)
Memo
263
HIACE (EM04Z2E)
Front Air Conditioner (2TR-FE, 1KD-FTV, 2KD-FTV)
(BAT) (IG)
40A 10A
HTR GAUGE
L–W
2 1B 1 A (LHD)
4 B (RHD)
B–R
HI
Blower Resistor (Front A/C)

1 5L
5 2
H1(A), (B)
4 HTR
Relay
3 1
M2 M1 E
3 A 2 A 4 A (LHD)
2 B 3 B 1 B (RHD)
12 5E 7 5M 7 5F 5 5Q 2 5E 4 5Q
L
W–B
W–B
W–B
L–B
R
L
Blower Motor (Front A/C)
2 3
L–R
L–R
L
2 HI M2 M1 LO E
M OFF

H2
1 LO
M1
L–W
M2
L
H14
HI
20 6C 6 1 8
H41
L–W
Junction
10 Connector
W–B
L–W
21 6C 22 6C
12 1 13
L
W–B
W–B
W–B
L–R
L–R
W–B
B3 H1
264
HIACE (EM04Z2E)
H18
A/C Amplifier
PHTR BLW A. C LED+ GND PRE S5 PS SG–1
5 16 8 9 29 4 13 21 12
L–W
G–B
(∗2)
(∗2)
W–B
Y
L–W
Y–R
R–L
(∗1)
V
L
6 IH2
3 HH1 4 HH1 28 HA1 27 HA1 21 HA1
G–B
(∗3)
(∗3)
Y
L–W
Y–R
L–W
G–B
(∗2)
(∗2)
Y
10 6D
Off
A/C Pressure Sensor No. 2

Y–R
Y–R
R–L
(∗1)
(∗1)
V
On 4 3
3 2 3 3 2
B AIND
PR + + PR 11 6D
Idle–Up SW
A/C Pressure
Sensor No. 1
L–W
I6
– –
A26
4
A4
1 1 36 HA1 (RHD)
3 HA1 (LHD)
L–W
L–W
(∗1)
L
W–B
2 H16
A/C SW L–W
W–B
L–O
I12(A), I13(B)
7 B
Connector
Junction
4
7 A
7. 5A A/C
W–B
Fuse Box
H34
3
17 IH3 (LHD)
17 IH4 (RHD)
8 6F
W–B
1 6F 7 6F
L
W–B
W–B
W–B
L–R L–R
L–R L–R
W–B
H2
265
HIACE (EM04Z2E)
∗ 2 : Before Oct. 2006 Production, RHD From Oct. 2006 Production ∗ 7 : 2KD–FTV
until Apr. 2009 Production ∗ 8 : 1KD–FTV, 2KD–FTV
∗ 3 : LHD From Oct. 2006 Production, RHD From Apr. 2009 Production ∗ 9 : 2TR–FE
∗ 4 : Shielded ∗10 : w/ Volume SW
∗ 5 : w/o Volume SW
∗ 6 : 1KD–FTV
H18
A/C Amplifier
TAM ALT HR TE SG FRBV MHSW
25 37 6 24 31 22 38
B–W
(∗2)
(∗2)
G–W
B
R–B
L–B
W
W
4 HA1 14 HB1 5 HH1 6 HH1
B–W
(∗3)
(∗3)
B
G–W
W
Ambient Temp. Sensor
1 10
Connector
B–W
L–B
L–B
L–B
(∗2)
(∗2)
W
Junction
B
B35
A/C Evaporator Temp.
8
1 7 8 6
Sensor (Front A/C)
A14
5 6E 6 6D 7 6D E B L
W
12 6D (∗5)
2
(∗10)
(∗10)
L–W
L–W
2 DB3
H8
4 6E 2 8 6D 9 6D Volume SW
21 HA1
R–B
L–B
L–B
L–B
(∗8)
W
29 HB1 IG
3 B H17 3 Off
M Rear Window
Defogger SW
Alternator
L–R
On
L–B
(∗8)
D6(B)
Max Hot SW
13 A (LHD)
14 B (RHD)
7 DB5
A H T EL
OFF
Control SW
Tail
L–B
(∗8)
Light
Head
AUTO
H28(A), H29(B) 16 A (LHD)

W–B
L–R
L–R
L–R
L–B
(∗8)
266
HIACE (EM04Z2E)
H18
A/C Amplifier
CANH CANL SPD
10 11 36
P–L
W
L
1 A 2 A
H3(A), H4(B), H5(C)

Junction Connector
1 C 2 C 1 B 2 B
W
W
R
Connector
Junction
6 14 11 HB4 22 HB4
H42
CANH CANL
8
W
B
H23
P–L
B7(B), D1(D) DLC3 33 B 34 B (∗9)
Engine ECU 24 B 23 B (∗8)
CANH CANL
Speed Sensor
THW E2 NE– NE+
D38
32 D 28 D 34 D 27 D (∗9) IG+ E SI
19 D 28 D 34 D 27 D (∗8) 1 2 3
P–L
R–W
Y–R
L–R
BR
P
(∗9)
B
Water Temp. Sensor
2 2
Connector
5 DB4 7 DB4 3 DB4 13 5H

Junction
4
(Engine Coolant)
Connector
Junction
D44
D44
BR
P
L–R
8
12
D32
14 5D
Y–R
1 22 HB1 58 HB1
(∗7, ∗9)
P–L
(∗6)
(∗9)
(∗7)
(∗6)
(∗4)
G
Y
L
BR
P–L
B–R
(∗4)
(∗8)
(∗4)
(∗9)
(∗8)
(∗9)
BR
5 9 3 2 1 BR
Connector
Connector
Junction
Junction
G– NE– NE
D43
D43
L–B
1 1 (∗8)
D17
W–B
(∗8)
(∗9)
BR
Crankshaft Position Sensor
L–R
L–B
(∗8)
D3 D2
267
HIACE (EM04Z2E)
until Apr. 2009 Production (BAT) (IG)
∗ 9 : 2TR–FE 10A 10A
ECU–B A/C
H18
A/C Amplifier
2 10 5M 28 5E
LOCK MGC IG+ B
28 19 20 40
W–R
R–B
R–B
(∗8)
(BAT)
(∗8)
R
L
W–R
10A 51 HB1
R–B
DOME
15 6E
2
17 5E
(∗8)
L
2
14 6E
R–B
R–B
(∗8)
(∗8)
R
3 DB5
3 5D
W–R
18 5E 4 4
W–R
(∗8)
L
2 3
R
8 5S MG CLT
Relay
13 HB1
R–B 7 4 R–B
1 5
H42
Junction 4 4
Connector
R
R–L
(∗9)
(∗8)
(∗8)
R
R
H20
5 Combination Meter R
B (∗8)
Speedometer
7 DB5 2 DB5
R–L
(∗8)
R–L
(∗8)
(∗8)
(∗9)
R
L
+S SI E3 E1
9 15 29 7
1 3 2
A/C Compressor
W–B
(∗2)
BR
P
P–L
A/C Compressor
D13
1
P
D14
1 HH1
BR
W–B
(∗9)
L–B
(∗8)
W–B
W–B
(∗2)
(∗3)
3 DB5
W–B
(∗9)
H2 B2
268
HIACE (EM04Z2E)
: Parts Location
48 (LHD) D17 54 (*5) H8 59 (RHD)
A4
58 (RHD) 44 (*1) 49 (LHD)
H14
48 (LHD) 45 (*2) 59 (RHD)
A14 D32
58 (RHD) 52 (*4) 49 (LHD)
H16
A26 48 (LHD) 55 (*5) 59 (RHD)
44 (*1) 44 (*1) 49 (LHD)
H17
45 (*2) 45 (*2) 59 (RHD)
B7 B D38
52 (*4) 52 (*4) 49 (LHD)
H18
54 (*5) 55 (*5) 59 (RHD)
44 (*1) 44 (*1) 49 (LHD)
H20
45 (*2) 45 (*2) 59 (RHD)
B35 D43
52 (*4) 52 (*4) 49 (LHD)
H23
54 (*5) 55 (*5) 59 (RHD)
44 (*1) 44 (*1) H28 A 49 (LHD)
45 (*2) 45 (*2) H29 B 59 (RHD)
D1 D D44
52 (*4) 52 (*4) 49 (LHD)
H34
54 (*5) 55 (*5) 59 (RHD)
44 (*1) A 49 (LHD) 49 (LHD)
H1 H41
45 (*2) B 59 (RHD) 59 (RHD)
D6 B
52 (*4) 49 (LHD) 49 (LHD)
H2 H42
54 (*5) 59 (RHD) 59 (RHD)
44 (*1) 42, 49 (LHD) 49 (LHD)
D13 H3 A I6
52 (*4) 42, 59 (RHD) 57 (RHD)
45 (*2) 42, 49 (LHD) 49 (LHD)
D14 H4 B I12 A
54 (*5) 42, 59 (RHD) 57 (RHD)
44 (*1) 42, 49 (LHD) 49 (LHD)
H5 C I13 B
D17 45 (*2) 42, 59 (RHD) 57 (RHD)
52 (*4) H8 49 (LHD)
: Relay Blocks

1B 24 Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
5F
5H
5L 30 Engine Room Main Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5M
5S
6C
6D
6E
6F
269
HIACE (EM04Z2E)
62 (*1)
63 (*2)
DB3
70 (*4)
71 (*5)
62 (*1)
63 (*2)
70 (*4)
71 (*5)
62 (*1)
63 (*2)
DB5
70 (*4)
71 (*5)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
HH1
66 (LHD)
74 (RHD)
IH3 66 (LHD)
IH4 74 (RHD)
: Ground Points
62 (*1)
70 (*4)
62 (*1)
63 (*2)
70 (*4)
71 (*5)
62 (*1)
D2
70 (*4)
Engine Block
63 (*2)
D3
71 (*5)
66 (LHD)
H1
74 (RHD)
66 (LHD)
H2
74 (RHD)
270
HIACE (EM04Z2E)
Memo
271
HIACE (EM04Z2E)
Front Air Conditioner (5L-E)
(BAT) (IG)
GAUGE
40A
10A
HTR
L
2 1B
B8(F), B10(E), D2(H), D4(G)

B–R
Engine ECU
L–W
1 5L 1 A (LHD) HSW NE+ NE–

4 B (RHD) 20 E 19 H 18 H
HI
L–W
5 2
4 HTR
(Shielded)
Blower Resistor (Front A/C)
Relay 14 HB2
L
L–W
3 1
2
H1(A), (B)
6 IH2
Engine Speed
12 5E 7 5M 7 5F 5 5Q
L–W
Sensor
Blower Motor (Front A/C)
D18
W–B
W–B
M2 M1 E 3
1
3 A 2 A 4 A (LHD)
Idle–Up SW
2
2 B 3 B 1 B (RHD)
M
I6
H2
1 4
W–B
L–W
L–B
W–B
L–W L–W
I12(A), I13(B)
7 B
Connector
Junction
6 2 3
HI M2 M1 LO E
7 A
OFF
L
6
Connector
W–B
LO
Junction
D43
M1
20 6C 21 6C 17 IH3 (LHD) 1
17 IH4 (RHD)
M2
W–B
HI
22 6C H14 1 8
10 13
Connector

Junction
12
L
H41
W–B
L
W–B
1
W–B
W–B
BR
B3 H1 D4
272
HIACE (EM04Z2E)
∗ 2 : Before Oct. 2006 Production, RHD From Oct. 2006 Production (IG)
∗ 4 : w/ Volume SW 10A
A/C
L L
Water Temp. Sensor
1 10 5M 27 5B 28 5E
(Engine Coolant)
D32
R–B
Off
R–B
R–B
2
B8(F), B10(E), D2(H), D4(G)
3 On 2
R–W
Y–R
R–B
R–B
1
AIND L
4 G 9 G
THW E2
Engine ECU
Pressure SW
AC1 ACT
2 F 8 F
B
A5
6 4
Connector
4 H16 4
Junction
A/C SW
G–W
R–B
H42
R–L
(∗2)
Y
29 HB1 51 HB1
(∗3)
3 HH1 28 HA1
Y
R–B
R–B
R–B
G–W
R–B
4 4
R–L
(∗2)
Y
8 10 11 13 3 2 3
AC1 ACT A. C IG+ PRE
MG CLT
Relay
H19
A/C Amplifier
GND FRBV TE SG MGC
1 5
6 12 4 16 15
4 4
L–B
W
R
(∗2)
B
R–L
R
5 HH1 9 6C 6 6D 13 HB1
W–B
(∗3)
B
10 6C 8 6C 8 6D
10 DB1
L–B
(∗2)
W
B
R–L
8 6F
8 7 1
A/C Compressor
B E
(∗1) 1
Sensor (Front A/C)
1 6F
(∗4)
(∗4)
D15
Volume SW
W–B
H8
2
H17
H2
273
HIACE (EM04Z2E)
Front Air Conditioner (5L-E)
: Parts Location
48 (LHD) 46 (*3) 49 (LHD)
A5 D32 H17
58 (RHD) 56 (*6) 59 (RHD)
46 (*3) 46 (*3) 49 (LHD)
B8 F D43 H19
56 (*6) 56 (*6) 59 (RHD)
46 (*3) A 49 (LHD) 49 (LHD)
B10 E H1 H41
56 (*6) B 59 (RHD) 59 (RHD)
46 (*3) 49 (LHD) 49 (LHD)
D2 H H2 H42
56 (*6) 59 (RHD) 59 (RHD)
46 (*3) 49 (LHD) 49 (LHD)
D4 G H8 I6
56 (*6) 59 (RHD) 57 (RHD)
46 (*3) 49 (LHD) 49 (LHD)
D15 H14 I12 A
56 (*6) 59 (RHD) 57 (RHD)
46 (*3) 49 (LHD) 49 (LHD)
D18 H16 I13 B
56 (*6) 59 (RHD) 57 (RHD)
: Relay Blocks

1B 24 Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
5M
5Q
6C
6D
6F

64 (*3)
72 (*6)
66 (LHD)
74 (RHD)
66 (LHD)
HB1
74 (RHD)
66 (LHD)
HB2
74 (RHD)
HH1
66 (LHD)
74 (RHD)
IH3 66 (LHD)
IH4 74 (RHD)
274
HIACE (EM04Z2E)
: Ground Points
64 (*3)
72 (*6)
64 (*3)
D4 Engine Block
72 (*6)
66 (LHD)
H1
74 (RHD)
66 (LHD)
H2
74 (RHD)
275
HIACE (EM04Z2E)
PTC Heater (2KD-FTV)
(BAT) (IG)
40A 10A
HTR GAUGE
2 1B
B–R
1 5L
5 2
4 HTR
Relay
3 1
12 5E 7 5M 7 5F 5 5Q 4 5Q
W–B
W–B
L–R
L–B L–B
Blower Motor
L–B
L–B
HI M2 M1 LO E
(Front A/C)
R–B
OFF
3 eB1 1 eB1 2 eB1 (∗1)
LO
3 eB2 1 eB2 2 eB2 (∗2)
M1
R–B
L–B
B
M2
1 A 3 A 2 A
HI
B B B
L
H14 1 8
e1(A), e2(B)
PTC Heater
W–B
20 6C
L
W–B
E E
1 B 2 B
W–B
W–B
21 6C 22 6C
12
Connector
2 eB3 1 eB3 (∗1)

Junction
2 eB4 1 eB4 (∗2)

H41
1
W–B
W–B
L–R
W–B
W–B
W–B
B3 H1 B4
276
HIACE (EM04Z2E)
(BAT) (BAT)
∗ 1 : Wide Body
∗ 2 : Standard Body
50A 50A ∗ 3 : Before Oct. 2006 Production, RHD From Oct. 2006 Production
PTC1 PTC2 until Apr. 2009 Production
H18
1 1F 1 1H A/C Amplifier
PTCL PTC MHSW BLW SG–1 TAM
R
3 2 38 16 12 25
W
GR
LG
G–W
B–W
L–W
(∗3)
L
54 HB1 16 HB1
4 HA1
GR
6 HH1
W–B
(∗4)
LG
G–W
L–W
GR
B–W
(∗3)
1 1 1 1 1
10 6D
Ambient Temp.
5 1 5 1
6
Sensor
A14
PTC1 PTC2 L
Relay Relay 12 6D 2
L–W
L–W
3 2 3 2
Defogger SW
1 1 1 1 Rear Window
21 HA1
H17
L–B IG
W–B
W–B
R–B
3 Off
R–B
L–R
On
Max Hot SW
W–B
W–B
L–R
L
W–B
W–B
B3
277
HIACE (EM04Z2E)
(BAT) (IG)
10A 10A
ECU–B A/C
H18
A/C Amplifier
2 10 5M
GND CANH CANL IG+ B
29 10 11 20 40
W–R
R–B
W–R
W–B
W
L
R–B
15 6E
17 5E
7
Connector
Junction
14 6E
H3(A), H4(B)
H42
Connector
1 A 2 A
Junction
4
3 5D
W–R
1 B 2 B
W–R
R–B
W
B
11 HB4 22 HB4
W
B
W–B
24 B 23 B
B7(B), D1(D)
CANH CANL
Engine ECU
THW E2
19 D 28 D
8 6F
R–W
Y–R
Water Temp. Sensor
2 2
Connector
Junction
(Engine Coolant)
1 6F
D44
W–B
8
D32
Y–R
1
W–B
H2
278
HIACE (EM04Z2E)
: Parts Location
48 (LHD) 42, 49 (LHD) 49 (LHD)
A14 H3 A H41
58 (RHD) 42, 59 (RHD) 59 (RHD)
45 (*2) 42, 49 (LHD) 49 (LHD)
B7 B H4 B H42
54 (*5) 42, 59 (RHD) 59 (RHD)
45 (*2) 49 (LHD) 48 (LHD)
D1 D H14 e1 A
54 (*5) 59 (RHD) 58 (RHD)
45 (*2) 49 (LHD) 48 (LHD)
D32 H17 e2 B
55 (*5) 59 (RHD) 58 (RHD)
45 (*2) 49 (LHD)
D44 H18
55 (*5) 59 (RHD)
: Relay Blocks

1B
1F 24 Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
1H
5M
5Q
6C
6D
6E
6F

66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
HH1
67 (LHD)
eB1
75 (RHD)
67 (LHD)
eB2
75 (RHD)
Heater Wire and Engine Room Main Wire (Near the A/C Unit)
67 (LHD)
eB3
75 (RHD)
67 (LHD)
eB4
75 (RHD)
279
HIACE (EM04Z2E)
: Ground Points
63 (*2)
71 (*5)
66 (LHD)
B4 Cowl Side Panel LH
74 (RHD)
66 (LHD)
H1
74 (RHD)
66 (LHD)
H2
74 (RHD)
280
HIACE (EM04Z2E)
Memo
281
HIACE (EM04Z2E)
Multiplex Communication System (CAN)
H18
A/C Amplifier
∗ 1 : 2TR–FE
CANH CANL ∗ 2 : 1KD–FTV, 2KD–FTV
∗ 3 : 1KD–FTV
10 11 ∗ 4 : 2KD–FTV
W
L
H3(A), H4(B), H5(C), H6(D)
1 A 2 A Junction Connector
ST–Plug
2
1 B 2 B 1 C 2 C 1 D
W
B
W–B
11 HB4 22 HB4
W
R
1 5S
W
B
12 5E 7 5M
33 B 34 B (∗1)
24 B 23 B (∗2) 6 14
CANH CANL B7(B) CANH CANL
Engine ECU
CAN+ CAN–
22 B 21 B H23
DLC3
(∗2 A/T)
(∗2 A/T)
W
L
1 DB2 6 DB2
(∗2 A/T)
(∗2 A/T)
W
L
8 DO2 16 DO2 (∗3)

W–B
9 DO1 19 DO1 (∗4)
12
Connector
Junction
(∗2 A/T)
(∗2 A/T)
W–B
W
L
H41
21 A 20 A
CAN+ CAN–
W–B
O3(A)
Transmission
Control ECU
B3 H1
282
HIACE (EM04Z2E)
: Parts Location
44 (*1) H4 B 42, 59 (RHD) 49 (LHD)
H23
45 (*2) 42, 49 (LHD) 59 (RHD)
B7 B H5 C
52 (*4) 42, 59 (RHD) 49 (LHD)
H41
54 (*5) 42, 49 (LHD) 59 (RHD)
H6 D
42, 49 (LHD) 42, 59 (RHD) 48 (LHD)
H3 A O3 A
42, 59 (RHD) 49 (LHD) 58 (RHD)
H18
H4 B 42, 49 (LHD) 59 (RHD)

5M
5S

63 (*2)
71 (*5)
63 (*2)
DO1
DO2 71 (*5)
66 (LHD)
74 (RHD)
: Ground Points
62 (*1)
63 (*2)
70 (*4)
71 (*5)
66 (LHD)
74 (RHD)
283
HIACE (EM04Z2E)
Rear Air Conditioner
(BAT) (IG) (BAT)
15A 10A 30A

RR HTR A/C RR CLR
9 5M 10 5M 10 5S 28 5E 2 1C
Y–R
R–B
R–B
R–B
Y
R–B
R–W
10 5H 6 5D
6 VB1
4
Connector
Junction
1 1
R–W
H42
RR HTR
Relay 5 1
5
6 Vj1
4 RR CLR
Relay
R–B
R–W
3 2
25 5E 13 5D 4
GND Lo Me Hi
1 1 1
OFF
R–W
W–B
R–B
L–R
L–R
L
Lo
Blower SW
(Rear A/C)
6 2 Me
L–R
B IG Hi
j3
8 1 6
R–L(∗3)
W–B
L–W
R–Y(∗4)
L–W
L W–B
H11 3
Rear Blower SW
W–B
(Main)
W–B
4 Vj1
11 6F
W–B
5 VB1
10 6F
W–B
W–B
9 6F L
R–B
L–R
1 6F
W–B W–B
W–B
W–B
W–B
H2 B2 B3
284
HIACE (EM04Z2E)
∗ 3 : For production through approximately Dec. 2006
∗ 4 : For production from approximately Dec. 2006
L L
R–L R–L R–L R–L

(∗3)
L–R
L
L
10A Fuse
10A Fuse
(In Line)
(In Line)
R–L
R–G R
(∗4) (∗4)
R–L(∗4)
R–L(∗4)
1
(Rear A/C RH)

(Rear A/C LH)
2 B 2 B
Blower Motor
Blower Motor
M M
j1(B)
j6(B)
1 B 1 B
R–G
R–L
R–L
L–R
(∗3)
(∗3)
(∗3)
(∗3)
R
3
3 A 1 A 3 A 1 A
Blower Resistor
Noise Filter
(Rear A/C)
(In Line)
M M
j2
R–L(∗3) 2 A j1(A) 2 A j6(A)

4
Blower Motor Blower Motor
R–Y(∗4) (Rear A/C LH) (Rear A/C RH)
W–B
W–B
W–B
(∗3)
(∗3)
L–W
L
W–B W–B W–B
5 Vj1
L
2 VB1
L
L L L
R–B R–B
L–R L–R
W–B W–B
285
HIACE (EM04Z2E)
∗ 1 : 2TR–FE, 1KD–FTV, 2KD–FTV

∗ 2 : 5L–E
L
H18(A), H19(B)
A/C Amplifier
Blower Resistor
(Rear Heater)
RRTE SG SG–2 RRAC RMGV W–L 3
(Rear Heater)
Blower Motor
23 A 30 A 7 A 18 A (∗1)
2
7 B 16 B 18 B 9 B (∗2)
k2
M
k1
2
W–R
1
L–B
(∗2)
P(∗1)
R–Y
(∗2)
Y
6 6D
W–L
L–R
B
L
L–B
(∗1)
40 HB1 31 HB1 1 kP1 2 kP1 3 kP1 4 kP1 (LHD)

9 6D 1 kQ1 2 kQ1 3 kQ1 4 kQ1 (RHD)
R–Y
L–B
(∗2)
4 (RHD)
(RHD)
(RHD)
(RHD)
A/C Magnetic Valve
53 HB1 30 HB1
W–L
L–R
B
L
2 1
W–R
A/C NO. 3
L–B
(Rear A/C)
(LHD)
(LHD)
(LHD)
(LHD)
W–L
L–R
B
L
1 QP1 2 QP1 3 QP1 4 QP1

7. 5A
B16
4 VB1 (∗1) 3 VB1 (∗1) 2

(RHD)
(RHD)
(RHD)
(RHD)
3 VB1 (∗2) 4 VB1 (∗2)
W–L
L–R
B
L
4
W(∗2)
B
R–B
(∗1)
(∗1)
W
(∗2)
1 BP1 2 BP1 5 BP1 6 BP1
3 Vj1 2 Vj1
W–L
L–R
B
L
W
6 1 4
1
Sensor (Rear A/C)
HI M L E
OFF
Lo
j5
2 Me
Hi
L B24 8
Blower SW
R–B (Rear Heater)
W–B
L–R
W–B
286
HIACE (EM04Z2E)
: Parts Location
44 (*1) 49 (LHD) 51 (LHD)
H19 B j5
45 (*2) 59 (RHD) 61 (RHD)
46 (*3) 49 (LHD) 51 (LHD)
B16 H42 A
52 (*4) 59 (RHD) 61 (RHD)
j6
54 (*5) 51 (LHD) 51 (LHD)
A B
56 (*6) 61 (RHD) 61 (RHD)
j1
50 (LHD) 51 (LHD) 51 (LHD)
B24 B k1
60 (RHD) 61 (RHD) 61 (RHD)
49 (LHD) 51 (LHD) 51 (LHD)
H11 j2 k2
59 (RHD) 61 (RHD) 61 (RHD)
49 (LHD) 51 (LHD)
H18 A j3
59 (RHD) 61 (RHD)
: Relay Blocks
22 (*7)
23 (*8)

1C 24 Engine Room Main Wire and Engine Room J/B No.1 (Engine Compartment Front)
5H 30
31
5S
6D
6F

68 (LHD)
76 (RHD)
66 (LHD)
74 (RHD)
QP1 76 (RHD) Frame No.2 Wire and Frame Wire (Near the Fuel Tank)
68 (LHD)
VB1 Roof No.3 Wire and Engine Room Main Wire (Center Pillar LH)
76 (RHD)
68 (LHD)
Vj1 Roof No.3 Wire and Rear A/C Sub Wire (Left Side of Rear A/C Unit)
76 (RHD)
kP1 68 (LHD) Rear A/C Sub Wire and Frame Wire (Near the Rear Heater Unit)
kQ1 76 (RHD) Rear A/C Sub Wire and Frame No.2 Wire (Near the Rear Heater Unit)
: Ground Points
62 (*1)
63 (*2)
70 (*4)
71 (*5)
287
HIACE (EM04Z2E)
: Ground Points
62 (*1)
63 (*2)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
66 (LHD)
74 (RHD)
288
HIACE (EM04Z2E)
Memo
289
HIACE (EM04Z2E)
I GROUND POINT
∗ 2 : Costa Rica, Egypt, El Salvador, G. C. C. , Guatemala, Honduras, ∗17 : Egypt, G. C. C. , Russian
Malaysia, Nicaragua, Panama, Peru, Russia, South Africa, Ukraine, Vietnam ∗18 : ∗1, ∗2 ∗14, ∗15 ∗16, ∗15 ∗17
∗14 : Before Oct. 2006 Production ∗19 : 1KD–FTV
∗15 : From Oct. 2006 Production ∗20 : 2KD–FTV
∗16 : Algeria, Costa Rica, El Salvador, Guatemala, Honduras, Mexico,
D30 W–B 4 2 (Shielded)

(E)
Air Switching (∗1, ∗15 ∗16)
Valve 5 (Shielded)
D20 BR 6 (Shielded)
(GND)
Ignition Coil
(No. 1) 7 (Shielded)
D21 BR 8 (Shielded)
(GND)
Ignition Coil
(No. 2) 9 (Shielded)
D22 BR
(GND)
Ignition Coil
(No. 3)
BR Junction Connector
D23 (GND)
Ignition Coil
(No. 4) 2 12
10 BR BR BR H23
DB5 HB4 (SG)
DLC3
BR
D43
BR
D3 (E04)
Engine ECU (∗1, ∗15 ∗16) 11
3 BR BR B12
BR BD1 (E)
(ME01) (∗1, ∗15 ∗16) (∗1, ∗15 ∗16) Air Injection
Control Driver
BR 11 BR
(E03) (E1) D1
(∗18) D1 (2TR–FE) Engine ECU
1
W–B
(E02)
W–B
W–B
(E01)
D2 (2TR–FE)
BR B42
(GND)
(∗19) Injector Driver
(EDU)
9 9
B43 BR BR 13 2 BR BR B15
(GND) DB7 BD1 (GND)
Turbo Motor (∗19) (∗19) (∗20) Injector Driver
Driver (EDU)
(Shielded) 13
BR BR 7 BR D48
DB7 (RSC)
(∗19) (∗19) (∗19) Throttle Body
Assembly
(Shielded) 3 4 BR D48
(E1)
(∗20) Throttle Body
Assembly
(Shielded) 9 12
5 10 BR BR BR H23
DB2 HB4 (SG)
DLC3
25 20
BR BR 6 11 BR D3
O1 (E01) DO2 DO1 (E1)
Transmission Engine ECU
(∗19) (∗20) D43
Control ECU 1 Junction
BR Connector
(E1) BR
(E01) D1
Engine ECU
BR
9 10
BR BR
DO2 DO1 (E02)
(∗19) (∗20)
D3 (1KD–FTV, 2KD–FTV)
290
HIACE (EM04Z2E)
I
D43
Junction
Connector
12 9 (Shielded)
H23 BR BR BR 10 6
(SG) HB4 DB1
DLC3
5 BR D63
(L)
(Shielded)
(Shielded)
Throttle
Position SW
4 3 BR D60
W–B 8 (E1)
A20 Injection
(LH E) Pump Assembly
Headlamp Leveling (LHD)
Motor (LH)
2 11 BR
3 (E1) D2
L5 W–B W–B 7 Engine ECU
(E) LA1
Power Window (LHD) (LHD) 1
Master SW BR
(E01)
Connector
BR
Junction
A22 W–B 4
(E) BR
A25
Cooling Fan Motor (Diesel)
No. 2 (E02)
3
W–B
D4 (5L–E)
A8 W–B
(RH E)
Headlamp Leveling (LHD)
Motor (RH)
W–B W–B
W–B
A5 (–S) (E) C2
Pressure SW (5L–E) Fog Lamp
(Front LH)
5
A23 W–B W–B W–B W–B C4
(E) CA1 (E)
Turn Signal Lamp Fog Lamp
(Front LH) (Front RH)
W–B W–B
W–B
A11 (E) (E) A10

Windshield Brake Fluid Level
Wiper Motor Warning SW
12 7
I9 W–B W–B W–B W–B A1
(E) IH2 HA1 (E)
Headlamp (LHD) (LHD) (LHD) Turn Signal Lamp
Leveling SW (Front RH)
W–B
A6 W–B
(E) 3
Clearance Lamp W–B W–B K5
(Front RH) KA1 (E)
(RHD) (RHD) Power Window
Master SW
W–B
A21 W–B
(E) W–B
Clearance Lamp
(Front LH)
A1 20 W–B (Shielded)
19 W–B (Shielded)
W–B
A24 (GND2)
Short Pin 18 W–B (Shielded)
(Vacuum)
W–B
Connector
W–B
(GND1)
Junction
17 W–B (Shielded)
B36
21 16
W–B W–B
B19 (GND) AB1
W–B
Skid Control ECU

with Actuator
12 6
W–B W–B W–B
(GND) AB1 AB1
W–B
W–B
W–B
14
W–B W–B W–B
HA2
A2
291
HIACE (EM04Z2E)
I GROUND POINT
W–B W–B
I4 (E) (E) I7
Hazard Warning (LHD) Door Lock
Signal SW Control SW
W–B W–B
(ILL–) (ILL–)
W–B
(LHD)
I5 W–B
(ILL–)
Room Lamp SW (RHD)
W–B
W–B
I12(A), I13(B) (ILL–) I6
Junction Idle–Up SW
Connector
W–B 10 7 W–B W–B
I9 (ILL–) A B (E)
Headlamp (LHD)
Leveling SW
W–B W–B 12 9 W–B

I15 (E) A B (E) I3
Power Slide Door (∗23) (∗23) Rear Fog
Control SW Lamp SW
W–B
(ILL–) 8
(∗23)
W–B
(∗23) W–B I8
B (E)
Outer Mirror
SW
W–B
I16 (E) 7 12
Power Slide Door (∗23) W–B I18
A B (TX3–)
Main SW Radio Receiver
W–B Assembly
(ILL–)
W–B
(∗23)
17 IH3 (LHD) W–B

17 IH4 (RHD)
W–B
13
12 W–B
H15 W–B 5 8 W–B

(E) (E) H9
Clearance Warning (RHD) Hazard Warning
Indicator Signal SW
H13 W–B 11 9 W–B

(ILL+) (ILL–)
Ashtray (RHD)
Illumination
H12 W–B 4 W–B H10

(E) (ILL–)
Cigarette (LHD) Room Lamp SW
Lighter
H41 ∗ 3 : w/ Power Window
H16 W–B 2 Junction
(ILL–) Connector ∗ 4 : w/o Power Window
A/C SW
∗ 6 : LHD, RHD 5L–E, RHD 2TR–FE ∗5, 1KD–FTV ∗5, RHD 2KD–FTV ∗5
W–B 10 ∗21 : Before Oct. 2006 Production, RHD From Oct. 2006 Production
H1 (E) until Apr. 2009 Production
Blower Resistor
(Front A/C) ∗22 : LHD From Oct. 2006 Production,
W–B 6 ∗23 : w/ Power Slide Door
H17 (E) ∗26 : 2TR–FE, 1KD–FTV, 2KD–FTV
Rear Window
Defogger SW
W–B 7 3 W–B
(ILL–) (ILL–) H14
Blower SW
1 (Front A/C)
W–B
(E)
W–B
W–B
W–B W–B W–B
H1
292
HIACE (EM04Z2E)
I
W–B
2
LG G(∗3) L1
LA2 (E)
(∗6) Door Lock
BR(∗4) Assembly
(Front LH)
25 2
LG LG G(∗3) K1
HA1 KA2 (E)
(∗6) (∗6) Door Lock
BR(∗4) Assembly
(Front RH)
W–B
(LFG) H28
(LHD) Combination SW
W–B
(EL)
(LHD)
W–B
(TB)
19 (LHD)
W–B W–B
6F
(∗6) 6
W–B
6F (LFG) H29
20 (RHD) Combination SW
H33 W–B
(E) 6F
Clearance
Warning ECU 7
W–B
6F (EL)
13 (RHD)
H22 W–B
(E) 6F
Shift Lock (A/T)
Control ECU 5
W–B
6F (TB)
14 (RHD)
H21 W–B
(ILL–) 6F
A/T Shift Lever
Illumination W–B
(GND) H18
(∗26) A/C Amplifier
11
W–B
H11 (L) 6F
Rear Blower SW 8
(Main) W–B H19
12 6F (GND)
W–B (5L–E) A/C Amplifier
(ILL–) 6F
3
W–B
W–B
16 6F (DBKL) H7
H26 (UN–) 6F (LHD ∗5) Integration
(A/T) Relay
Unlock Warning SW
15 4
W–B W–B H30
(KLS) 6F 6F (E)
(A/T) Combination SW
17 2
H27 W–B W–B H23
(KUL) 6F 6F (CG)
Unlock Warning SW (M/T) DLC3
10 6F 9 6F 1 6F
2 2
BR BR I2
W–B IH3 IH4 (GND)
Radio Receiver
W–B
(LHD)(RHD) Assembly
BR
(GND1) I18
BR
Radio Receiver
Assembly
W–B
(∗22)
1
W–B W–B W–B W–B H20
HH1 (E1)
(∗21) (∗21) Combination
Meter
H2
293
HIACE (EM04Z2E)
I GROUND POINT
W–B
4 25 11
L L L I5
BT1 HB2 IH2 (ILL–)
(∗7) (RHD ∗7) (RHD ∗7) Room Lamp SW
L H10
(ILL–)
(LHD ∗7) Room Lamp SW
1
W
5K
(∗7) HTR Relay
7
W–B
5M
IG1 Relay
(GND)
Flasher Relay Noise Filter
14
W–B
B4 (E1) 5E
Airbag Sensor PWR Relay
Assembly Center
30
W–B
(E2) 5E
12 11 1
W–B W–B
6C 6C 5C (GND)
(∗30) (∗30) Integration
Relay
(∗29)
W–B
1
W–B H6
5S (E1)
Junction
W–B 2 1 Connector
H44 (GND)
Transponder Key (∗29)
ECU 28
H46 W–B T5
5A (E)
Junction (∗7) Map Lamp
Connector
12 5E
W–B j3
Blower SW
(Rear A/C)
W–B W–B
W–B
j2
Blower Resistor
(Rear A/C)
W–B
B30 W–B 4 Vj1 W–B j1

(E)
Fuel Filter (Diesel) Blower Motor
Warning SW (Rear A/C LH)
W–B
W–B
B24 W–B B j6
(E)
Blower SW 5 VB1 Blower Motor
(Rear Heater) (Rear A/C RH)
W–B
W–B
W–B W–B
(–S) 4
ST Relay Noise Filter
(In Line)
4
W–B W–B W–B N1
(–S) 1 NB1 (E)
Slide Door Control
W–B
PTC1 Relay
Junction (Male LH)
1
W–B W–B W–B R1
(–S) 1 RB1 (E)
PTC2 Relay (RHD) (RHD) Front Seat Inner
Belt (Front
Passenger' s
6 Side)
H20 B–R W–B
(LP) HB1
Combination (w/o ABS) (w/o ABS)
Meter W–B
(E) B32
Door Control
Relay (LH)
W–B
2 2
W–B W–B
e2 (E) eB3 eB4 3
PTC Heater W–B W–B(∗25)
(∗8) (∗9) Bq1
1 1 (∗25)
W–B W–B W–B
(E) eB3 eB4 W–B
(∗8) (∗9)
B4 B3
294
HIACE (EM04Z2E)
I
∗ 7 : w/ Map Lamp
∗ 8 : Wide Body
∗15 : From Oct. 2006 Production
∗16 : Algeria, Costa Rica, El Salvador, Guatemala, Honduras, Mexico,
∗24 : 1KD–FTV, 2KD–FTV
∗25 : w/ Power Slide Door
Except RHD From Sep. 2007 Production
∗30 : RHD w/ Engine Immobiliser System W–B
8
W–B
From Sep. 2007 Production DB4 (E) D11
(2TR–FE) Engine Oil
Level Sensor
W–B D12
(E)
(∗24, 5L–E) Engine Oil
Level Sensor
W–B W–B
(–S) 1 1 (E)
GLOW Relay (Diesel) RR CLR Relay
8 3
W–B
(–S) 1 BP1 Ph1 (E) h2
FAN1 Relay Fuel Suction
Pump and
Gage Assembly
W–B W–B B21

(–S) 1 (–)
FAN2 Relay (Diesel) Fuel Sedimentary
Level Warning SW
15
3
W–B W–B 12 13 W–B B9
1I (EC)
A/F Relay (∗1, ∗15 ∗16) (2TR–FE) Engine ECU
B36
Junction
W–B
3 Connector
W–B W–B B7
1J (EC)
MAIN Relay (∗24) Engine ECU
3
B11 W–B W–B W–B D13
(E) DB5 (–)
Front Seat (RHD) (2TR–FE) (2TR–FE) A/C Compressor
Inner Belt
(Driver' s Side)
2
W–B W–B
W–B
MB1 (E) M1
Slide Door Control
Junction (Male RH)
8
W–B W–B M2
MB1 (E)
Door Control
Relay (RH)
1
W–B W–B R2
RB1 (E)
(LHD) (LHD) Front Seat
Inner Belt
(Driver' s Side)
B17 W–B
(GND) W–B
Air Pump (∗1, ∗15 ∗16) (BZR–) q2
(∗25) Slide Door
Warning Buzzer
B27 W–B
(E1) W–B W–B
Cooling Fan q3
ECU No. 1 (GND)
(∗25) (∗25) Door Control Relay
(Power Slide Door)
(∗25)
W–B
W–B
W–B
B28 (E2)
Cooling Fan W–B q4
ECU No. 2 (GND)
(∗25) Door Control Relay
3 oq1 (Power Slide Door)
(∗25)
W–B
W–B(∗25) 8 po1
W–B
(∗25)
W–B
(GND) p2
W–B W–B (∗25) Door Opening
Relay
B1 B2 p1
295
HIACE (EM04Z2E)
I GROUND POINT
∗10 : w/ Rear Wiper

∗11 : w/o Rear Wiper
∗28 : Except ∗27
T16 W
(E)
Rear Combination
Lamp (LH)
Y2 W–B
(GND)
Door Control
Receiver
2 3
d1 W BR BR
(E) dT1 TY2
Center Stop Lamp (∗11) (∗11) (∗11)
(∗10)
B
1 1 3
b2 B B B W–B
(–) db2 dT1 TY1
Rear Window (∗10) (∗10) (∗10) (∗10)
Defogger
U2
Junction
Connector
U1 W 3 2
(E)
Rear Combination
Lamp (RH)
1
W–B
GR
9 ZU1 3 TU2 (∗28)

3 TU3 (∗27)
W–B
W–B
9 Za1 5 TY2 4 TY2
a2 B
(–)
Back Door
Courtesy SW
3
Connector
Junction
a4 BR 2
W–B(∗10)
(E)
BR(∗11)
License Plate
W–B
W–B
W–B
a1
Lamp
1
W–B
a1 Y1
296
HIACE (EM04Z2E)
I
: Parts Location
48 (LHD) 45 (*2) 49 (LHD)
A25 I12 A
58 (RHD) 46 (*3) 57 (RHD)
44 (*1) D43 52 (*4) 49 (LHD)
I13 B
45 (*2) 55 (*5) 57 (RHD)
46 (*3) 56 (*6) 51 (LHD)
B36 U2
52 (*4) 49 (LHD) 61 (RHD)
H41
54 (*5) 59 (RHD) 51 (LHD)
a1
56 (*6) 49 (LHD) 61 (RHD)
H46
D43 44 (*1) 59 (RHD)
: Relay Blocks
22 (*7)
23 (*8)

1I
1J
5K 30 Roof Wire and Instrument Panel J/B (Left Side of Instrument Panel)
5M
5S
6C 38 (RHD) Instrument Panel Wire and Center J/B (Instrument Panel Reinforcement RH)
6F

66 (LHD)
74 (RHD)
62 (*1)
63 (*2)
70 (*4)
71 (*5)
68 (LHD)
76 (RHD)
66 (LHD)
74 (RHD)
66 (LHD)
74 (RHD)
64 (*3)
DB1
72 (*6)
63 (*2)
DB2
71 (*5)
63 (*2)
DB4 64 (*3)
70 (*4)
71 (*5)
297
HIACE (EM04Z2E)
I GROUND POINT
DB4 72 (*6)
DB5
70 (*4)
DB7 71 (*5) Engine Wire and Engine Room Main Wire (Front Floor Panel Right)
63 (*2)
DO1
DO2 71 (*5)
66 (LHD)
HA1
74 (RHD)
Instrument Panel Wire and Cowl to Head Lamp Wire (Under the Instrument Panel J/B)
66 (LHD)
HA2
74 (RHD)
66 (LHD)
HB1
74 (RHD)
66 (LHD)
HB2
74 (RHD)
66 (LHD)
74 (RHD)
HH1
66 (LHD)
74 (RHD)
IH3 66 (LHD)
IH4 74 (RHD)
KA1 75 (RHD)
KA2
75 (RHD)
LA1 67 (LHD)
LA2
75 (RHD)
62 (*1)
63 (*2)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
62 (*1)
63 (*2)
64 (*3)
NB1 Pillar No.2 Wire and Engine Room Main Wire (LH Side Battery Room)
70 (*4)
71 (*5)
72 (*6)
68 (LHD)
76 (RHD)
68 (LHD)
RB1 Seat No.2 Wire and Engine Room Main Wire (Center Pillar LH)
76 (RHD)
68 (LHD)
TU2
76 (RHD)
68 (LHD)
TU3
76 (RHD)
68 (LHD)
TY1
76 (RHD)
Roof Wire and Luggage Room No.3 Wire (Left Quarter Panel)
68 (LHD)
TY2
76 (RHD)
68 (LHD)
VB1 Roof No.3 Wire and Engine Room Main Wire (Center Pillar LH)
76 (RHD)
Vj1 68 (LHD) Roof No.3 Wire and Rear A/C Sub Wire (Left Side of Rear A/C Unit)
298
HIACE (EM04Z2E)
I
Vj1 76 (RHD) Roof No.3 Wire and Rear A/C Sub Wire (Left Side of Rear A/C Unit)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
76 (RHD)
68 (LHD)
db2 Back Door No.3 Wire and Rear Window No.1 Wire (Near the Rear Wiper Motor)
76 (RHD)
67 (LHD)
eB3
75 (RHD)
Heater Wire and Engine Room Main Wire (Near the A/C Unit)
67 (LHD)
eB4
75 (RHD)
: Ground Points
66 (LHD)
A1 Dash Panel Right
74 (RHD)
66 (LHD)
A2 Dash Panel Left
74 (RHD)
62 (*1)
63 (*2)
64 (*3)
B1
70 (*4)
71 (*5)
72 (*6)
62 (*1)
63 (*2)
64 (*3)
B2
70 (*4)
71 (*5)
72 (*6)
62 (*1)
63 (*2)
64 (*3)
70 (*4)
71 (*5)
72 (*6)
66 (LHD)
B4 Cowl Side Panel LH
74 (RHD)
62 (*1)
D1
70 (*4)
62 (*1)
D2
70 (*4)
Engine Block
63 (*2)
D3
71 (*5)
64 (*3)
D4
72 (*6)
66 (LHD)
H1
74 (RHD)
66 (LHD)
H2
74 (RHD)
299
HIACE (EM04Z2E)
I GROUND POINT
: Ground Points
68 (LHD)
a1 Back Door Right
76 (RHD)
p1 76 (RHD) Near the Slide Door Handle LH
300
HIACE (EM04Z2E)
Memo
301
HIACE (EM04Z2E)
The chart below shows the route by which current flows from the battery to each electrical source
(Fusible Link, Circuit Breaker, Fuse, etc.) and other Parts.
[LOCATION] * 1:2TR-FE
1 : Engine Room R/B No.1 and Engine Room J/B No.1 (See Page 22)
2 : Engine Room R/B No.2 (See Page 28)
4 : Instrument Panel R/B (See Page 29)
HEAD Relay
40A HEAD 2 (Point Side) 4
30A AM2 2
10A DOME
30A D.C.C 2 2
15A RADIO
7.5A ALT-S
10A ECU-B
10A ETCS
25A ABS SOL

Battery FL MAIN 2.0L 2
30A RR DOOR
40A ABS MTR
25A PSD
15A TVSS
120A MAIN 4 1
30A FAN3
50A FAN1
50A FAN2 1
50A PTC1
50A A/PUMP (*1) 1
50A PTC2
80A GLOW (*2)
FL MAIN 3.0W 140A ALT 1 30A RR CLR 1
40A HTR 1
15A A/F
15A HAZ-HORN
50A MAIN3 1 1
20A EFI (*1)
25A EFI (*2)
302
HIACE (EM04Z2E)
J
Example
Starter S1
Parts Code or Location

5 : Instrument Panel J/B (See Page 30)
6 : Fuse Box (H34 on See Page 49 (LHD), 59 (RHD))
7.5A DRL 4
15A HEAD LH Location

4
15A HEAD RH Electrical Source
10A MET IGN

Ignition SW
(AM2) H25 5
15A IGN
7.5A OBD
10A STOP
15A FR FOG
5
15A RR FOG
15A RR HTR
7.5A ECU-IG
30A DOOR
10A A/C
10A GAUGE
IG1 Relay
(Point Side) 5 5
15A RR WIP-WSH
20A WSH
25A WIP
DEF Relay
30A DEF 5 (Point Side) 5 10A ELS 5
PWR Relay
(Point Side) 5 30A PWR 5
10A PANEL
T-LP Relay
(Point Side) 5 5
10A TAIL
7.5A ACC
Ignition SW
30A AM1 5 (AM1) H25 5
15A CIG
RR CLR Relay
(Point Side) 1 7.5A A/C NO.3 4
7.5A ST 4
HTR Relay
(Point Side) 5 7.5A A/C 6
303
HIACE (EM04Z2E)
Engine Room R/B No.1 and Engine Room J/B No.1 (See Page 22)
Fuse System Page
15A A/F Engine Control (2TR-FE) 94
Horn 238
15A HAZ-HORN
Turn Signal and Hazard Warning Light 134
ECT and A/T Indicator (2TR-FE) 206
20A EFI
Engine Control (2TR-FE) 94
ECT and A/T Indicator (1KD-FTV, 2KD-FTV) 212
25A EFI Engine Control (1KD-FTV, 2KD-FTV) 104
Engine Control (5L-E) 114
Cooling Fan (2TR-FE, 1KD-FTV, 2KD-FTV) 256
30A FAN3
Cooling Fan (5L-E) 260
30A RR CLR Rear Air Conditioner 284
Front Air Conditioner (2TR-FE, 1KD-FTV, 2KD-FTV) 264
40A HTR Front Air Conditioner (5L-E) 272
PTC Heater (2KD-FTV) 276
50A A/PUMP Engine Control (2TR-FE) 94
50A FAN1
50A FAN2
50A PTC1 PTC Heater (2KD-FTV) 276
50A PTC2 PTC Heater (2KD-FTV) 276
Engine Control (1KD-FTV, 2KD-FTV) 104
80A GLOW
Automatic Light Control and Light Auto Turn Off System 156
Combination Meter and Clock 250
Front Fog Light 128
Illumination 146
Key Reminder and Light Reminder 230
120A MAIN4
Parking Assist (TOYOTA Parking Assist-Sensor) 242
Power Window (LHD) 166
Power Window (RHD) 170
Rear Fog Light 130
Starting 84
Taillight 142
Charging (2TR-FE, 1KD-FTV, 2KD-FTV) 88
140A ALT Charging (5L-E) 90
Starting 84
* These are the page numbers of the first page on which the related system is shown.
304
HIACE (EM04Z2E)
J
Engine Room R/B No.2 (See Page 28)
Fuse System Page
7.5A ALT-S
Charging (5L-E) 90
10A DOME
Illumination 146
Interior Light 150
Power Slide Door 186
Door Lock Control (LHD) 174
Door Lock Control (RHD) 180
Engine Immobiliser System (1KD-FTV, 2KD-FTV) 122
Engine Immobiliser System (2TR-FE) 120
10A ECU-B Front Air Conditioner (2TR-FE, 1KD-FTV, 2KD-FTV) 264
Interior Light 150
Wireless Door Lock Control (LHD) 194
Wireless Door Lock Control (RHD) 200
10A ETCS
15A RADIO Audio System 248
25A ABS SOL ABS 220
25A PSD Power Slide Door 186
30A AM2 Ignition 92
Starting 84
Door Closer 190
30A RR DOOR
40A ABS MTR ABS 220
40A HEAD
Headlight 126
305
HIACE (EM04Z2E)
Fuse System Page
40A HEAD Headlight Beam Level Control 160
Instrument Panel R/B (See Page 29)

Fuse System Page
7.5A A/C NO.3 Rear Air Conditioner 284
7.5A ST Engine Control (2TR-FE) 94
Starting 84
Headlight 126
15A HEAD LH
Headlight Beam Level Control 160
15A HEAD RH Headlight 126
Instrument Panel J/B (See Page 30)

Fuse System Page
Audio System 248
7.5A ACC Remote Control Mirror 234
Shift Lock 228
ABS 220
7.5A ECU-IG Interior Light 150
Shift Lock 228
DLC3 124
7.5A OBD
10A A/C Front Air Conditioner (5L-E) 272
Rear Air Conditioner 284
10A ELS
Rear Window Defogger 240
10A GAUGE Back-Up Light 140
306
HIACE (EM04Z2E)
J
Fuse System Page
Charging (5L-E) 90
10A GAUGE
Front Air Conditioner (5L-E) 272
Seat Belt Warning 232
Turn Signal and Hazard Warning Light 134
ABS 220
Charging (5L-E) 90
10A MET IGN Engine Control (2TR-FE) 94
Seat Belt Warning 232
SRS 223
Taillight 142
Illumination 146
10A PANEL Key Reminder and Light Reminder 230
Taillight 142
ABS 220
10A STOP ECT and A/T Indicator (1KD-FTV, 2KD-FTV) 212
307
HIACE (EM04Z2E)
Fuse System Page
10A STOP Engine Control (5L-E) 114
Shift Lock 228
Stop Light 138
Front Fog Light 128
10A TAIL
Rear Fog Light 130
Taillight 142
15A CIG Cigarette Lighter 236
Front Fog Light 128
15A FR FOG
Rear Fog Light 130
15A IGN
Engine Immobiliser System (1KD-FTV, 2KD-FTV) 122
Engine Immobiliser System (2TR-FE) 120
SRS 223
15A RR FOG Rear Fog Light 130
15A RR HTR Rear Air Conditioner 284
15A RR WIP-WSH Rear Wiper and Washer 164
20A WSH Front Wiper and Washer 162
25A WIP Front Wiper and Washer 162
30A AM1 Starting 84
30A DEF
30A DOOR
30A PWR
Fuse Box (H34 on See Page 49 (LHD), 59 (RHD))

Fuse System Page
7.5A A/C Front Air Conditioner (2TR-FE, 1KD-FTV, 2KD-FTV) 264
308
HIACE (EM04Z2E)
Memo
309
HIACE (EM04Z2E)
K CONNECTOR LIST
A1 A2 A3 A4 A5
Gray Black Black Black Dark Gray
1 2
1 2 3 4 5 1
1 2 1 2 3 2 3
4
A6 A7 A8 A9 A10
Black Black Gray Gray
1
2 3
1 2 1 1 2
1 2
3
A11 A12 A13 A14 A15 A16

Black Yellow Yellow Black Black Black
1 1
1 2 3 1 2 1 2 1 2
4 5
A17 A18 A19 A20 A21

Black Gray Black Black
1
2 3
1 2 1 2 1 2 1 2
3
A22 A23 A24 A25

Black Gray Dark Gray
3 2 1
1 2 6 5 4
1 2
1 2 3 4
5 6 7 8
A26 A27 B1 B2 B3
Black Black Black
1
1 2 3 4 5 1 2 3 4 5 6
1 2 3 1 2
3 4
For all additional information, refer to the end of this section.
310
HIACE (EM04Z2E)
K
B4 B5 B6 B7
Yellow Yellow Yellow
1 2 3 4 5 1 2 3 4 5
1 2 3 4 5 6 7 8 9 10
6 7 8 9 10 6 7 8 9 10 1 2 3 4 5 6
11 12 13 14 15 16 17 18 19 20
7 8 9 10 11 12 13 14 15 16
11 12 13 14 15 11 12 13 14 15 17 18 19 20 21 22 23 24 25 26 27
21 22 23 24 25 26 27 28 29 30
28 29 30 31 32 33 34 35
B8 B9 B10 B11
1 2 3 4 5 6 1 2 3 4 5 6 7 8 9 10 11
1 2
1 2 3 4 5 6 7 12 13 14 15 16 17 18 19 20 21 22
7 8 9 10 11 12
8 9 10 11 12 13 14 15 16 17
18 19 20 21 22 23 24 25
26 27 28 29 30 31
B12 B13 B14

Black Black Gray
1 2 3 4 5 6
1 2 3 4 5 6 7 8
1 2
B15 B16 B17 B18

Dark Gray Gray Gray Black
1 2 1 2 1 2
1 2 3 4 5 6 7 8
B19 B20 B21 B22

Black Gray Black Black
1
1 2 1 2
3 4 5 6 7 8 9 10 11 12
1 2
13 14 15 16 17 18 19 20 21 22
23 24
25 26 27 28 29 30 31 32 33 34
311
HIACE (EM04Z2E)
K CONNECTOR LIST
B23 B24 B25 B26 B27
Yellow Blue Yellow Black Gray
1 2 3 4 5
1 2 1 2 1
6 7 8 1 2 3
B28 B29 B30 B32 B33

Black Black Gray Gray
1 2 1
1 2 1 2 3 4 5 2
1 2 3
B34
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
B35
Black
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
B36 B37
Black
1 2 3 4
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
312
HIACE (EM04Z2E)
K
B38 B39 B40 B40 B41
Black Black (*1) Gray (*2) Black (*1) Black
1 2
1 2 3 1 2 3
3 4
1 2 3 4 1 2 3 4 4 5 6 4 5 6
B41 B41 B42 B42 B43

(*3) (*4) Gray (*3) Gray (*5)
1 2 3 4 5
1 2 1 2 6 7 8 9 10 11 12
1 2 3 1 2 3
3 4 3 4
4 5 6 4 5 6
B44 C1 C2 C3 C4
Gray Black Brown Black Brown
1 2 1 2
1 2 1 2
1 2
3 4
D1 D2 D3
1 2 3 4 5 6 7 8 9 10 11 12 13
1 2 3 4 5 6 7 14 15 16 17 18 19 20 21 22 23 24 25 26 1 2 3 4 5 6 7
8 9 10 11 12 13 14 15 16 17 8 9 10 11 12 13 14 15 16 17 18 19
18 19 20 21 22 23 24 25 26 27 20 21 22 23 24 25 26 27
28 29 30 31 32 33 34 28 29 30 31 32 33 34 35
D4 D5 D5 D6 D7
(*1) (*2) Green Black
1 1
1 2 3 4 5 6 7 8 1 2
1
9 10 11 12 13 14 15 16 3 4
D8 D9 D10 D11 D12 D13

Gray Black Gray Gray
1
1 2
1 2 1 2
1 2 1 2
313
HIACE (EM04Z2E)
K CONNECTOR LIST
D14 D15 D16 D17 D18 D19
Gray Gray Black Gray Gray
1
1 1 2
1 2 1 2
1 2
3 3
D20 D21 D22 D23 D24

Black Black Black Black Brown
1 2
1 2 3 4 1 2 3 4 1 2 3 4 1 2 3 4
D25 D26 D27 D28 D29

Gray Brown Gray Black Black
1 2 1 2 1 2
1 2 3 4 5 6
1 2
D30 D31 D32 D33 D34 D35

Black Black Black Dark Gray Dark Gray Dark Gray
1 2 1 2
1 2 1 2
1 2
1 2 3 4 3 4 3 4
3
D36 D37 D38 D39 D40

Gray Gray Black Gray Black
1 2 3 1 2
1 2 1 2 3 4 1 2
5 6 7 8 9
D41 D42 D43

Gray Black Black
1 2 3 4
1 2
5 6 7 8
1 2 3 4 5
6 7 8 9 10 11 12 13
314
HIACE (EM04Z2E)
K
D44 D45 D46 D47
Blue Black Dark Gray Gray
1 2 1 2
1 2 3
1 2 3 4 5
6 7 8 9 10 11 12 13
D48 D49 D50 D51 D52

Black Gray Black Black Black
1 2 3
1 2 3 1 2 3
1 2 1 2 3
D53 D53 D54 D55 D56

(*6) (*7) Brown
1 1 1
1 2
1 2
D57 D58 D59 D60 D61 D62

Black Gray Gray Black Brown Black
1 2 1 2
1 2 3 1 2
1 2 3 1 2 3 4
4 5 6
D63 D64 D65 D66 D67

Black Gray Black Black Blue
1 2
1 2 3 4 5 6
1 2 1 2 1 2
D68 D69 E1 E1 E1
Brown Black (*10) (*11) (*12)
1 1 1
1 2 3
1 2
4 5 6
315
HIACE (EM04Z2E)
K CONNECTOR LIST
E1 E1 E1 E2 E2
(*8) (*9) (2TR-FE) (*13) Black (2TR-FE) Black
1 1 1
1
1
H1 H2 H3 H4 H5 H6
Black Black
1
1 2 1 1 1
1 2
3 4 2 2 2
H7 H8 H9 H10
Black Gray
1 2 1 2 3 4 5 6 1 2 3 4 5 6
1 2 3 10 11 12
4 5 6 7 8 9
13 14 15 16 17 18 19 20 21 22 23 24 25 26
H11 H12 H13 H14 H15

Black Gray Black
1 2 3 4 5
1 2
1 2 1 2 3 4 5 6 7
3 4 5 6 1 2 6 7 8
8 9 10 11 12 13 14
H16 H17 H18

Gray Black Black
1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
1 2 3 4 5 6 7 8
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
H19 H20 H21

Black Black
1 2 3 4 5 6 7 8 1 2
9 10 11 12 13 14 15 16 17 18
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
316
HIACE (EM04Z2E)
K
H22 H23 H24 H25
Gray
1 2
1 2 3 4 5 6
1 2 3 4
7 8 9 10 11 12
16 15 14 13 12 11 10 9 5 6 7 8
8 7 6 5 4 3 2 1
H26 H27 H28 H29

Gray
1 2 1 2 1 2 6 7 8
1 2 3 4 5 6 7 8 3 4 5
3 4
9 10 11 12 13 14 15 16 17 9 10 11 12 13 14 15 16 17
H30 H31 H32

Black Black Yellow
1 2 3 4 5 6 1 2
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
H33 H34 H35 H36

Blue Black Black
1 2 1 2
1 2 3 4
1 2 3 4 5 6 7 8 9 10 11 12 13
14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
H37 H38 H39 H40 H41

Black Black Black Black Black
1 2 3
1 2 1 2 1 2
1 2 3 4 5
6 7 8 9 10 11 12 13
317
HIACE (EM04Z2E)
K CONNECTOR LIST
H42 H43
Black Black
1 2 3 4 5 6 7
1 2 3 4 5 6 7 8 9 10 11
12 13 14 15 16 17 18 19 20 21 22
H44 H45 H46 H47

Black Black Gray
1 2 1 2 3
1 2 3 4 5
1 2 3 4
6 7 8 9 10 11 12 13 14 15 16
H48 H49 H50 H51

Black Black
1 2 3 4
1 2 3 4 5 6 7 8 9 10 1 2
1 2 3 4
11 12 13 14 15 16 17 18 19 20
I1 I2 I3 I4 I4
Blue (*14) Black (*15) Gray
1 2 1 2 3 4
3 4 5 6 5 6 7 8 9 10 1 2 3 4 5 6 1 2 3 4 5 6
1 2 3 4
5 6 7 8
I5 I6 I7 I8 I9
Gray Black Black Gray
1 2 1 2
1 2 3 4 5 6 1 2 3 4 5 6 3 4 5 6 3 4 5 6
1 2 3 4 5 6 7 8 9 10
318
HIACE (EM04Z2E)
K
I10 I11 I12
Black Black Blue
1 2 3 4 1 2 3 4
1 2 3 4 5 6
7 8 9 10 11 12
I13 I14 I15 I16

Blue Black Green Gray
1 2 3 4 1 2 3 4 5
1 2 3 4
1 2 3 4 5 6
7 8 9 10 11 12
I17 I18 I19 J1

Orange
1 2 3 4 5
6 7 8 9 10 11 12 1 2 3 4 5 6 7 8 1 2
1 2 3
9 10 11 12 13 14 15 16 17 18
4 5 6
K1 K2 K3 K4
Black
1 2
1 2 3 4 1 2 1 3 3 4 5 6
5 6 7 8 9 10 2
5 4
K5 K6 L1 L2
1 2 3 4 5 1 2 3 4 1
1 2 3 4 5 6 7 8 9
5 6 7 8 9 10 2
10 11 12 13 14 15 16 17 18
319
HIACE (EM04Z2E)
K CONNECTOR LIST
L3 L4 L5 L6
Black
1 2
2 1 1 2 3 4 5
3 3 4 5 6
1 2 3 4 5 6 7 8 9
5 4
10 11 12 13 14 15 16 17 18
M1 M2 M3 N1 O1
Gray
1
1 2 3 4 5 1 2 3 4 5 2 1 2 3 4 5
1 10
2 3 4 5 6 7 8 9
11 12 13 14 15 16 17 18 19 20 21 22
23 24 25 26 27 28 29 30
O2 O3 R1 R2
Blue Blue
1 2 1 2
1 2 5 6 1 2 3 4 5 6
3 4
7 8 9 10 11 12 13 14 15 16 7 8 9 10 11 12 13 14 15 16 17
17 18 19 20 21 22 23 24 18 19 20 21 22 23 24 25 26
T1 T2 T3 T4
Black Black Black
1
1 2 3 4 1 2 3 4 1 2 3 4
2
T5 T6 T7 T8 T9 T10 T11
1 2 3
1 2 3 1 2 3
1 2 3
1 1 1
2 2 2
320
HIACE (EM04Z2E)
K
T12 T13 T14
Blue
1 2 3
1
2
1 2 3 4 5
6 7 8 9 10 11 12 13
T15 T16 T17 T18 T19

Black
1 2 1 2 1 2 1 2
3 4
1 2 3 4 5 5 6
6 7 8 9 10 11 12
T20 T21 U1 U2 W1
Black Black
1 2
1 2 1 2 3 1 2
3 4
1 2 3 4
5 6
W2 W3 W4 X1 X2 Y1
Black Black Black
1 2 1 2 1 2
1
1 1
2 2
Y2 Y3 Y4 Y4 a1
(*3) Black (*5) Black
1
1 2 3 4 1 2 3 4
1 2 3 4 5 1 2 3 4
a2 a3 a4 b1 b2 d1
Gray Black Black
1 1
1 2
2 1 2 1
2 1
321
HIACE (EM04Z2E)
K CONNECTOR LIST
d2 e1 e2 g1 h1
Black Dark Gray
1 2
1 2 3
1 2 3
1 2 3 1 2 4 5
h2 j1 j1 j2 j3
Dark Gray (*16) Black (*17) Gray Black Black
1 2 3 1 2 3 4 5
1 2 1 2 3
1 2 6 7 8
4 5
3 4
j5 j6 j6 k1 k2 m1
(*16) Black (*17) Black Black Black Gray
1
1 2 1 2 1 2 3 2
1 2
1 2
3 4
m2 n1 n2 p1 p2
Black Gray Gray
1 2 3 4 5
6 7 8 9 10 11 12
4 3 2 1
1 2 1 2
1 2 10 9 8 7 6 5
p3 p4 p5 p6 q1 q2
Black Gray Gray Black
1 2
1 2 3 4 2 1 1 2
1 2 1 2
3 4
3 4
5 6
q3 q4 q5 q6
Blue Gray
1 2 3 4 1
1 2 3 2
5 6 7 8 9 10
1 2 3 10 11 12 4 5
4 5 6 7 8 9
13 14 15 16 17 18 19 20 21 22 23 24 25 26
322
HIACE (EM04Z2E)
Memo
323
HIACE (EM04Z2E)
K CONNECTOR LIST
AB1 Gray AB2 Yellow
2 1
2 3 4 3
1 4 1 2
6 7 8 9 10 11
5 12 3 4
14 15 16 17 18 19 20
13 21 3 2
22 23 24 25 26 4 1
11 10 9 8 7 6
12 5
20 19 18 17 16 15 14
21 13
26 25 24 23 22
BD1 Gray BE1 Gray
1 1
1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18 18 17 16 15 14 13 12 11 10
BP1 Black BP2 Dark Gray
4 3 2 1 3 2 1
1 2 3
1 2 3 4 6 5 4
8 7 6 5 4 5 6
5 6 7 8
BP3 Black
1 2 3 4 5 5 4 3 2 1
6 7 8 9 10 10 9 8 7 6
324
HIACE (EM04Z2E)
K
BT1
7 8 9 10 11 12
1 2 3 4 5 6
13 14 15 16 17 18
19 20 21 22 23 24 12 11 10 9 8 7
25 26 27 28 29 30 6 5 4 3 2 1
18 17 16 15 14 13
30 29 28 27 26 25 24 23 22 21 20 19
BT2 Bq1
1 2 3 4 4 3 2 1
1 2 3 4
5 6 7 8 9 10 4 3 2 1 8 7 6 5
5 6 7 8
10 9 8 7 6 5
Bq2 Black CA1 Black
3 2 1
1 2 3 4 5 5 4 3 2 1 1 2 3 6 5 4
6 7 8 9 10 10 9 8 7 6 4 5 6
DB1 Gray
1 2 3 4 5 6 7
7 6 5 4 3 2 1
8 9 10 11
11 10 9 8
12 13 14 15 16 17 17 16 15 14 13 12
325
HIACE (EM04Z2E)
K CONNECTOR LIST
DB2 Black DB3 Dark Gray
1 2 3 4 5 5 4 3 2 1 1 2 3 4 4 3 2 1
6 7 8 9 10 10 9 8 7 6
5 6 7 8 8 7 6 5
12 11 10 9
9 10 11 12
DB4 Gray DB5 Black
4 3 2 1 4 3 2 1
1 2 3 4 1 2 3 4
8 7 6 5 8 7 6 5
5 6 7 8 5 6 7 8
DB6 DB7 Gray
1 1
9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9
25 16 15 14 13 12 11 10 17
17 10 11 12 13 14 15 16 25 24 23 22 21 20 19 18
18 19 20 21 22 23 24
DO1
1 2 3 4 5 6 7 8 9 10 10 9 8 7 6 5 4 3 2 1
11 12 13 14 15 16 17 18 19 20 20 19 18 17 16 15 14 13 12 11
326
HIACE (EM04Z2E)
K
DO2 Dg1 Black
2 1
9 8 7 6 5 4 3 2 1
1 2
1 2 3 4 5 6 7 8 9
25 16 15 14 13 12 11 10 17
17 10 11 12 13 14 15 16 25 24 23 22 21 20 19 18
18 19 20 21 22 23 24
HA1
7 8 9 10 11 12 13 14 15
1 2 3 4 5 6
16 17 18 19 20 21 22 23 24
25 26 27 28 29 30 15 14 13 12 11 10 9 8 7
31 32 33 34 35 36 37 38 39 6 5 4 3 2 1
24 23 22 21 20 19 18 17 16
39 38 37 36 35 34 33 32 31 30 29 28 27 26 25
HA2 Blue
1 2 2 1
5 5
3 4 6 7 7 6 4 3
8 9 10 11 12 12 11 10 9 8
13 14 15 15 14 13
HB1
7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
1 2 3 4 5 6
23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38
39 40 41 42 43 44 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7
45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 6 5 4 3 2 1
38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23
60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39
327
HIACE (EM04Z2E)
K CONNECTOR LIST
HB2 HB3 Yellow
2 1
2 3 4 3
1 4 1 2
6 7 8 9 10 11
5 12 3 4
14 15 16 17 18 19 20
13 21 3 2
22 23 24 25 26 4 1
11 10 9 8 7 6
12 5
20 19 18 17 16 15 14
21 13
26 25 24 23 22
HB4 Gray HH1
1 2 3 4 5 6 7 8 9 10 11 11 10 9 8 7 6 5 4 3 2 1 1 2 3 4 5 5 4 3 2 1
12 13 14 15 16 17 18 19 20 21 22 22 21 20 19 18 17 16 15 14 13 12 6 7 8 9 10 10 9 8 7 6
HJ1 Yellow IH1
2 1 1 2 3 4 5 6 7 8
1 2 9 10 11 12 13 14 15 16 17 18 8 7 6 5 4 3 2 1
18 17 16 15 14 13 12 11 10 9
IH2
1 2 3 4 5 6 7 8 9 10 10 9 8 7 6 5 4 3 2 1
11 12 13 14 15 16 17 18 19 20 20 19 18 17 16 15 14 13 12 11
328
HIACE (EM04Z2E)
K
IH3 Gray
1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18 18 17 16 15 14 13 12 11 10
IH4 Gray KA1
1 2 3 3 2 1
1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1 6 5 4
4 5 6
10 11 12 13 14 15 16 17 18 18 17 16 15 14 13 12 11 10
KA2 KA3
Black Gray Gray Black
4 3 2 1 4 3 2 1
1 2 3 4 1 2 3 4
8 7 6 5 8 7 6 5
5 6 7 8 5 6 7 8
LA1 LA2
Black Gray
3 2 1 4 3 2 1
1 2 3
6 5 4 1 2 3 4
4 5 6 8 7 6 5
5 6 7 8
LA3 MB1
Gray Black
4 3 2 1 4 3 2 1
1 2 3 4 1 2 3 4
8 7 6 5 8 7 6 5
5 6 7 8 5 6 7 8
329
HIACE (EM04Z2E)
K CONNECTOR LIST
NB1 OB1 Ph1 Dark Gray
3 2 1 2 1
1 2 3 1 2
1 2 3 4 5 6
6 5 4 6 5 4 3 2 1 4 3
4 5 6 3 4
Pn1 QP1 Black RB1

Black Gray
2 1 2 1 1 2
1 2 1 2
3 4 4 3 3 4 4 3
2 1
SP1 Black TU1
4 3 2 1
1 2 3 4
8 7 6 5 1 2 3 4 5 5 4 3 2 1
5 6 7 8
6 7 8 9 10 10 9 8 7 6
TU2 TU3
1 2 3 4
1 2 3 4
5 6 7 8 9 10 11 4 3 2 1 4 3 2 1
5 6 7 8 9 10 11
11 10 9 8 7 6 5 11 10 9 8 7 6 5
TY1 TY2
1 2 3 4
4 3 2 1
5 6 7 8 9 10 1 2 3 4 5 5 4 3 2 1
10 9 8 7 6 5
6 7 8 9 10 10 9 8 7 6
330
HIACE (EM04Z2E)
K
UX1 VB1 Vj1
1 2
1 2 3 4 1 2
4 3 2 1 2 1
3 4
5 6 7 8 9 10 10 9 8 7 6 5 3 4 5 6 2 1
4 3
5 6
6 5 6 5 4 3
WS1 Black ZU1
4 3 2 1 1 2 3 4
1 2 3 4 4 3 2 1
8 7 6 5
5 6 7 8 9 10 11
5 6 7 8 11 10 9 8 7 6 5
Za1 dT1 db1
1 2 3
1 2 3 4 4 5 6 7 8 1
4 3 2 1 1
5 6 7 8 9 10 11 3 2 1
11 10 9 8 7 6 5 8 7 6 5 4
db2 eB1 Gray eB2 Blue
1 1
3 2 1 3 2 1
1 2 3 1 2 3
eB3 Gray eB4 Blue kP1 Black
1 2 2 1
2 1 2 1 3 4 4 3
1 2 1 2
331
HIACE (EM04Z2E)
K CONNECTOR LIST
kQ1 Black
1 2 2 1
3 4 4 3
oq1 Gray
1 2 3 4 5 6 7
7 6 5 4 3 2 1
8 9 10 11
11 10 9 8
12 13 14 15 16 17 17 16 15 14 13 12
po1
1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1
10 11 12 13 14 15 16 17 18 18 17 16 15 14 13 12 11 10
332
HIACE (EM04Z2E)
K
*1 : Before Sep. 2007 Production
*2 : From Sep. 2007 Production
*3 : From Apr. 2009 Production
*4 : From Sep. 2007 Production until Apr. 2009 Production
*5 : Before Apr. 2009 Production
*6 : 1KD-FTV Before Sep. 2007 Production, 2KD-FTV
*7 : 1KD-FTV From Sep. 2007 Production
*8 : 1KD-FTV, 2KD-FTV M/T Except Cold Area Spec.
*9 : 2KD-FTV A/T Cold Area Spec.
*10 : 2KD-FTV A/T Except Cold Area Spec.
*11 : 5L-E Cold Area Spec.
*12 : 5L-E Except Cold Area Spec.
*13 : 1KD-FTV, 2KD-FTV, 5L-E
*14 : Before Oct. 2006 Production
*15 : From Oct. 2006 Production
*16 : For production from approximately Dec. 2006
*17 : For production through approximately Dec. 2006
333
HIACE (EM04Z2E)
A1 Turn Signal Lamp (Front RH) 90980-11019 B20 Speed Sensor (Front LH) 90980-11075
A2 Inlet Air Temp. Sensor (Air Cleaner) 90980-11163 B21 Fuel Sedimentary Level Warning SW 90980-12416
A3 Air Flow Meter 90980-12292 B22 Door Courtesy SW (Front LH) 90980-12470
A4 A/C Pressure Sensor No.1 90980-10845 B23 Front Seat Outer Belt (LH) 90980-12253
A5 Pressure SW 90980-10943 B24 Blower SW (Rear Heater) 90980-10463
A6 Clearance Lamp (Front RH) 90980-11156 B25 Front Seat Outer Belt (RH) 90980-12253
A7 Headlamp (RH) 90980-11314 B26 Door Courtesy SW (Front RH) 90980-12470
A8 Headlamp Leveling Motor (RH) 90980-11016 B27 Cooling Fan ECU No.1
90980-10841
A9 Brake Vacuum Warning SW 90980-11252 B28 Cooling Fan ECU No.2
A10 Brake Fluid Level Warning SW 90980-11207 B29 Water Temp. Sensor (Radiator) 90980-10735
A11 Windshield Wiper Motor 90980-11599 B30 Fuel Filter Warning SW 90980-11003
A12 Airbag Sensor (Front RH) B32 Door Control Relay (LH) 90980-10789
90980-12490
A13 Airbag Sensor (Front LH) B33 Step Lamp (LH) 90980-10121
A14 Ambient Temp. Sensor 90980-11070 B34 Junction Connector
A15 Horn (Low) B35 Junction Connector 90980-11915
90980-10619
A16 Horn (High) B36 Junction Connector
A17 Windshield Washer Motor 90980-11019 B37 Junction Connector
A18 Rear Washer Motor 90980-11051 B38 Junction Connector 90980-11398
A19 Headlamp (LH) 90980-11314 B39 Junction Connector
A20 Headlamp Leveling Motor (LH) 90980-11016 B40 Injector Driver (EDU) 90980-11144
A21 Clearance Lamp (Front LH) 90980-11156 B41 Injector Driver (EDU) 90980-11028
A22 Cooling Fan Motor No.2 90980-10928 B42 Injector Driver (EDU) 90980-11194
A23 Turn Signal Lamp (Front LH) 90980-11019 B43 Turbo Motor Driver 90980-10803
A24 Short Pin (Vacuum) 90980-10987 B44 Option Connector (TVSS Siren) 90980-10942
A25 Junction Connector 90980-10891 C1 Ultrasonic Sensor No.1 (Front LH) 90980-11246
A26 A/C Pressure Sensor No.2 90980-10845 C2 Fog Lamp (Front LH) 90980-11096
A27 Air Flow Meter 90980-11317 C3 Ultrasonic Sensor No.1 (Front RH) 90980-11246
B1 Accelerator Position Sensor 90980-11858 C4 Fog Lamp (Front RH) 90980-11096
B2 Stop Lamp SW 90980-11118 D1 Engine ECU 90980-12527
B3 Parking Brake SW 90980-10182 D2 Engine ECU 90980-11390
B4 Airbag Sensor Assembly Center 90980-12391 D3 Engine ECU 90980-12528
B5 Airbag Sensor Assembly Center 90980-12449 D4 Engine ECU 90980-11391
B6 Airbag Sensor Assembly Center 90980-12450 Alternator (Before Sep. 2007 Production) 90980-09373
D5
B7 Engine ECU 90980-12529 Alternator (From Sep. 2007 Production) 82675-26220
B8 Engine ECU 90980-11408 D6 Alternator 90980-11964
B9 Engine ECU 90980-12525 D7 Engine Oil Pressure SW 90980-11363
B10 Engine ECU 90980-11392 D8 Engine Oil Pressure SW 90980-10703
B11 Front Seat Inner Belt (Driver's Side) 90980-10825 D9 Noise Filter (Ignition) 90980-10843
B12 Air Injection Control Driver 90980-11858 D10 Camshaft Position Sensor 90980-10947
B13 Injector Driver (EDU) 90980-11592 D11 Engine Oil Level Sensor 90980-11235
B14 Air Injection Control Driver 90980-12068 D12 Engine Oil Level Sensor 90980-10532
B15 Injector Driver (EDU) 90980-11593 D13 A/C Compressor 90980-11156
B16 A/C Magnetic Valve (Rear A/C) 90980-11003 D14 A/C Compressor 90980-11016
B17 Air Pump 90980-11032 D15 A/C Compressor 90980-11271
B18 Speed Sensor (Front RH) 90980-11003 D16 Power Steering Oil Pressure SW 90980-11428
B19 Skid Control ECU with Actuator 90980-12020 D17 Crankshaft Position Sensor 90980-11016
Note:Not all of the above part numbers of the connector are established for the supply.
334
HIACE (EM04Z2E)
L
D18 Engine Speed Sensor 90980-11250 D62 Crankshaft Position Sensor 90980-11162
D19 Camshaft Timing Oil Control Valve 90980-11162 D63 Throttle Position SW 90980-11156
D20 Ignition Coil (No.1) D64 Pressure Discharge Valve 90980-11285
D21 Ignition Coil (No.2) Turbocharger Variable Nozzle Motor
90980-11885 D65 90980-11156
Assembly
Turbocharger Variable Nozzle Motor
D23 Ignition Coil (No.4) D66 90980-12303
Assembly
D24 Fuel Injector (No.1) D67 Swirl Control Valve 90980-11156
D25 Fuel Injector (No.2) D68 VSV (EGR Cut) 90980-11149
90980-11875
D26 Fuel Injector (No.3) D69 Fuel Pressure Sensor 90980-11194
D27 Fuel Injector (No.4) Starter
D28 VSV (Purge) 90980-11156 (1KD-FTV, 2KD-FTV M/T Except Cold Area 82675-26290
Spec.)
D29 Throttle Body Assembly 90980-11858
Starter (2KD-FTV A/T Cold Area Spec.) 82675-26300
D30 Air Switching Valve 90980-11149
E1 Starter
82675-26310
D31 Variable Resistor 90980-10902 (2KD-FTV A/T Except Cold Area Spec.)
D32 Water Temp. Sensor (Engine Coolant) 90980-10735 Starter (2TR-FE) 90980-09506
D33 Air Fuel Ratio Sensor (Bank 1 Sensor 1) Starter (5L-E Cold Area Spec.) 90980-09508
90980-10869
D34 Heated Oxygen Sensor (Bank 1 Sensor 1) Starter (5L-E Except Cold Area Spec.) 90980-09507
D35 Heated Oxygen Sensor (Bank 1 Sensor 2) 90980-11028 Starter (1KD-FTV, 2KD-FTV, 5L-E) 90980-11184
E2
D36 Back-Up Lamp SW 90980-11250 Starter (2TR-FE) 90980-11400
D37 Park/Neutral Position SW 90980-12362 H1 Blower Resistor (Front A/C) 90980-11136
D38 Speed Sensor 90980-11143 H2 Blower Motor (Front A/C) 90980-10916
D39 A/T Fluid Temp. Sensor 90980-11162 H3 Junction Connector
D40 Transmission Revolution Sensor (Input) 90980-11156 H4 Junction Connector 90980-12355
D41 ECT Solenoid 90980-10891 H5 Junction Connector
D42 Transmission Revolution Sensor (Output) 90980-11156 H6 Junction Connector 90980-10871
D43 Junction Connector H7 Integration Relay 90980-12444
90980-11542
D44 Junction Connector H8 A/C Evaporator Temp. Sensor (Front A/C) 90980-11918
D45 Fuel Pressure Sensor 90980-10845 H9 Hazard Warning Signal SW
90980-10957
D46 Fuel Temp. Sensor 90980-10737 H10 Room Lamp SW
D47 Suction Control Valve 90980-11285 H11 Rear Blower SW (Main) 90980-10797
D48 Throttle Body Assembly 90980-11145 H12 Cigarette Lighter 90980-12498
D49 Inlet Air Temp. Sensor (Intake Manifold) 90980-11025 H13 Ashtray Illumination 90980-10825
D50 Throttle Body Assembly 90980-11261 H14 Blower SW (Front A/C) 90980-10463
D51 Turbo Pressure Sensor 90980-10845 H15 Clearance Warning Indicator 90980-11911
D52 EGR Valve Position Sensor 90980-11143 H16 A/C SW 90980-12550
Glow Plug H17 Rear Window Defogger SW 90980-12558
(1KD-FTV Before Sep. 2007 Production, 99141-13004
2KD-FTV) H18 A/C Amplifier 90980-12557
D53
Glow Plug H19 A/C Amplifier 90980-10819
82675-26110
(1KD-FTV From Sep. 2007 Production) H20 Combination Meter 90980-12557
D54 Glow Plug 90980-09320 H21 A/T Shift Lever Illumination 90980-12063
D55 VRV (EGR) 90980-11162 H22 Shift Lock Control ECU 90980-12552
D56 A/T Fluid Temp. Sensor 90980-11025 H23 DLC3 90980-11665
D57 Manifold Absolute Pressure Sensor 90980-10845 H24 Ignition Key Cylinder Lamp 90980-11148
D58 Throttle Body Assembly 90980-11144 H25 Ignition SW 90980-11615
D59 Spill Control Valve 90980-12117 H26 Unlock Warning SW 90980-10795
D60 Injection Pump Assembly 90980-11028 H27 Unlock Warning SW 90980-10860
D61 Timer Control Valve 90980-11285
335
HIACE (EM04Z2E)
H28 Combination SW 90980-11672 K2 Speaker (Front Door RH) 90980-10935
H29 Combination SW 90980-11671 K3 Outer Rear View Mirror (RH) 90980-12189
H30 Combination SW 90980-11594 Power Window Regulator Motor
K4 90980-10797
(Front RH)
H31 Spiral Cable 90980-11986
K5 Power Window Master SW 90980-12122
H32 Airbag Squib (Steering Wheel Pad) 90980-11886
K6 Power Window SW (Front RH) 90980-10789
H33 Clearance Warning ECU 90980-12422
L1 Door Lock Assembly (Front LH) 90980-12226
H34 Fuse Box -
L2 Speaker (Front Door LH) 90980-10935
H35 Diode (Door Courtesy No.1)
90980-10962 L3 Outer Rear View Mirror (LH) 90980-12189
H36 Diode (Door Courtesy No.2)
L4 Power Window Regulator Motor (Front LH) 90980-10797
H37 Diode (Door Courtesy No.3) 90980-11251
L5 Power Window Master SW 90980-12122
H38 Diode (Headlight)
L6 Power Window SW (Front LH)
H39 Diode (Automatic Light Control No.1) 90980-10962
M1 Slide Door Control Junction (Male RH) 90980-10789
H40 Diode (Automatic Light Control No.2)
M2 Door Control Relay (RH)
H41 Junction Connector 90980-11542
M3 Step Lamp (RH) 90980-10121
N1 Slide Door Control Junction (Male LH) 90980-10789
H43 Transponder Key Amplifier 90980-12092
O1 Transmission Control ECU 90980-12562
H44 Transponder Key ECU 90980-12423
H45 Diode (Door Courtesy No.8) 90980-10962
H47 Diode (Power Slide Door) 90980-11071 R1
(Front Passenger's Side) 90980-10825
H48 Junction Connector 90980-11398 R2 Front Seat Inner Belt (Driver's Side)
H49 Option Connector (TVSS ECU) 90980-11971 T1 Junction Connector
Option Connector T2 Junction Connector 90980-11398
H50 90980-10860
(Clearance Warning Buzzer)
T3 Junction Connector
H51 Option Connector (Fuse Box) 82610-20080
T4 Room Lamp (Front) 90980-12343
I1 Radio Receiver Assembly 90980-10996
T5 Map Lamp 90980-10365
T6 Diode (Door Courtesy No.4) 90980-11071
I3 Rear Fog Lamp SW 90980-12113
T7 Room Lamp (Center) 90980-12343
I4 Hazard Warning Signal SW
90980-10957 T8 Room Lamp (Center) 90980-11987
I5 Room Lamp SW
I6 Idle-Up SW 90980-10933
T10 Speaker (Roof LH)
I7 Door Lock Control SW 90980-10996
T11 Speaker (Roof RH) 90980-12343
I8 Outer Mirror SW 90980-11657
T12 Room Lamp (Rear)
I9 Headlamp Leveling SW 90980-10996
T13 Room Lamp (Rear) 90980-11987
I10 Automatic Light Control Sensor 90980-11107
T14 Junction Connector 90980-12346
I11 Junction Connector 90980-11398
T15 Junction Connector 90980-10803
90980-11661 T16 Rear Combination Lamp (LH) 90980-11011
I14 Junction Connector 90980-11398
I15 Power Slide Door Control SW 90980-11013 90980-11608
I16 Power Slide Door Main SW 90980-10789
U1 Rear Combination Lamp (RH) 90980-11011
I19 Option Connector (TVSS Indicator Lamp) 90980-12012
U2 Junction Connector 90980-11398
Airbag Squib
J1 90980-12224
(Front Passenger's Airbag Assembly) W1 Ultrasonic Sensor No.1 (Rear LH)
90980-11246
K1 Door Lock Assembly (Front RH) 90980-12226 W2 Ultrasonic Sensor No.2 (LH)
Note:Not all of the above part numbers of the connector are established for the supply.
336
HIACE (EM04Z2E)
L
W3 Ultrasonic Sensor No.2 (RH) p6 Power Slide Door Sensor 90980-11002
90980-11246
W4 Ultrasonic Sensor No.1 (Rear RH) q1 Slide Door Motor Assembly 90980-10942
X1 Speaker (Rear RH) 90980-12343 q2 Slide Door Warning Buzzer 90980-11142
X2 Door Courtesy SW (Slide Door RH) 90980-11097 q3 Door Control Relay (Power Slide Door) 90980-10801
Y1 Speaker (Rear LH) 90980-12343 q4 Door Control Relay (Power Slide Door) 90980-12444
Y2 Door Control Receiver 90980-12366 q5 Slide Door Motor Assembly 90980-11599
Y3 Door Courtesy SW (Slide Door LH) 90980-11097 q6 Step Lamp (LH) 90980-10121
Option Connector
Y4 90980-11013
(Clearance Warning ECU)
a1 Junction Connector 90980-11398
a2 Back Door Courtesy SW 90980-11299
a3 Back Door Lock Assembly 90980-11300
a4 License Plate Lamp 90980-11395
b1 Rear Window Defogger
90980-11853
b2 Rear Window Defogger
d1 Center Stop Lamp 90980-11918
d2 Rear Wiper Motor 90980-12255
e1 PTC Heater 90980-10956
e2 PTC Heater 90980-10903
g1 Knock Control Sensor (Bank 1) 90980-11875
h1 Fuel Sender Gage
90980-11077
Blower Motor (Rear A/C LH)
(For production from approximately Dec. 90980-10916
2006)
j1
Blower Motor (Rear A/C LH)
(For production through approximately Dec. 90980-10908
2006)
j2 Blower Resistor (Rear A/C) 90980-11136
j3 Blower SW (Rear A/C) 90980-10463
j5 A/C Evaporator Temp. Sensor (Rear A/C) 90980-10825
Blower Motor (Rear A/C RH)
(For production from approximately Dec. 90980-10916
2006)
j6
Blower Motor (Rear A/C RH)
(For production through approximately Dec. 90980-10908
2006)
k1 Blower Motor (Rear Heater) 90980-10214
k2 Blower Resistor (Rear Heater) 90980-11136
Cooling Fan ECU No.1
m1
90980-10928
Cooling Fan ECU No.2
m2
n1 Speed Sensor (Rear LH)
90980-11467
p1 Slide Door Lock Assembly 90980-10800
p2 Door Opening Relay 90980-10803
p3 Door Control SW 90980-11011
p4 Slide Door Handle SW 90980-10825
p5 Slide Door Lock Remote Control Assembly 90980-11150
337
HIACE (EM04Z2E)
* The system shown here is an EXAMPLE ONLY. It is different to the
338
HOW TO READ THIS SECTION actual circuit shown in the wiring diagram section.
[A]
S ta rtin g E n g in e C o n tro l
1 2 3 4
B- R B- R
B- R
ACC
2
[M]
B- W
W 4 AM1 IG1 A11
1 (BAT) Heated Oxygen Sensor
ST1 1 B- W
7. 5A 15A
IGN EFI
8 AM2 IG2 7 B- R [L]
2 2
ST2 2 B- L
2 3 1
(2L- T) 2 2
W- R
GR
B
[B] A
A6
R- Y
B- W
Ignition SW R- Y R- Y
B- L B
B
R- Y
C
[E] 1 1
B- R
3 4
[H]
W EFI MAIN
B- L
(2L-T)
(2L- T) 7 BA3 Relay 12 BA1
B
[C] [J]
Y- R
(Shielded)
1 2
W
W- R
1 A 1 B
B- R
1 1
2 2 A40(A), A41(B) [I]
Starter
Y- R
Relay
B- W
21
B- W
W- B
Y- R Y- R Y- R
(22R- E)
2 2 BA3 D
2 A 2 B
Y- R
Y- R
2 3 7 3C
B- W
W- B
(2L-T)
(2L- T)
B- W
HIACE (EM04Z2E)
[F] 8 4
40A AM1
30A AM2
6 AB3
100A ALT
B- W
+B OX1
A19
Circuit Opening
Relay
M OVERALL ELECTRICAL WIRING DIAGRAM
(22R- E)
[G] 1 6 15 3C
B- W
1
B- R
R- G
(2L- T)
B- R B- R B- R FP E1
Emission ECU
< 9- 8>
B1
Data Link Connector 1
B- W
2 5 AD2 [D] 1 3
B- R
B- R
B- R
B- R
1 A
R- G
R- G
W- B
2 2 2 2
B
R- G
16 AD1
B 1
B M
17 BA3
B9
Injection No. 1
B11
Injection No. 2
B10
Injection No. 3
B12
Injection No. 4
R- G
1 1 1 1
B38(A), B39(B)
BR
BR
Starter
2
R- G
W- R
W- R
W- R
W- R
M W- R W- R W- R W- R
Battery
A37
Fuel Pump
E
1 W- R W- R
F
W- B
W- B
[K]
A1 A1 A3 B1
[A] : System Title [F] : Junction Block (The number in the circle is the J/B No.
and the connector code is shown beside it).
[B] : Indicates the wiring color.
Junction Blocks are shaded to clearly separate them
Wire colors are indicated by an alphabetical code. from other parts.
B = Black W = White BR = Brown
L = Blue V = Violet SB = Sky Blue Example:
R = Red G = Green LG = Light Green
3C indicates that
P = Pink Y = Yellow GR = Gray it is inside
Junction Block
O = Orange BE = Beige No.3
The first letter indicates the basic wire color and the
second letter indicates the color of the stripe.
Example: L–Y
[G] : Indicates related system.

[H] : Indicates the wiring harness and wiring harness
connector. The wiring harness with male
L Y terminal is shown with arrows ( ).
(Blue) (Yellow) Outside numerals are pin numbers.
[C] : The position of the parts is the same as shown in
the wiring diagram and wire routing.
[D] : Indicates the pin number of the connector.
The numbering system is different for female and
male connectors.
Example: Numbered in other Numbered in other Female Male ( )
from upper left to from upper right to
lower right lower left [I] : ( ) is used to indicate different wiring and
HIACE (EM04Z2E)
connector, etc. when the vehicle model, engine type,
or specification is different.
[J] : Indicates a shielded cable.
Female Male
The numbering system for the overall wiring diagram is

the same as above
[K] : Indicates a ground point.
[E] : Indicates a Relay Block. No shading is used and
[L] : The same code occurring on the next page indicates
only the Relay Block No. is shown to distinguish
that the wire harness is continuous.
it from the J/B.
Example: Indicates Relay Block No.1 [M] : Indicates the ignition key position(s) when the power is
supplied to the fuse(s).
M
339
SYSTEM INDEX
340
SYSTEMS LOCATION SYSTEMS LOCATION
ABS .................................................................................................. 16-1 Power Slide Door .............................................................................. 33-1
Audio System ................................................................................... 27-3 Power Source ..................................................................................... 1-1
Automatic Light Control ...................................................................... 9-1 Power Window (LHD) ....................................................................... 22-1
Back-Up Light ................................................................................... 12-1 Power Window (RHD) ...................................................................... 23-1
Charging ............................................................................................. 2-4 PTC Heater (2KD-FTV) .................................................................... 30-1
Cigarette Lighter ............................................................................... 17-4 Rear Air Conditioner ......................................................................... 32-1
Clock ................................................................................................. 28-1 Rear Fog Light .................................................................................. 10-3
Combination Meter ........................................................................... 28-1 Rear Window Defogger .................................................................... 27-1
Cooling Fan ...................................................................................... 29-1 Rear Wiper and Washer ................................................................... 24-3
DLC3 ................................................................................................ 29-4 Remote Control Mirror ...................................................................... 21-1
Door Closer ...................................................................................... 20-1 Seat Belt Warning ............................................................................. 25-2
Door Lock Control (LHD) .................................................................. 18-1 Shift Lock .......................................................................................... 21-4
Door Lock Control (RHD) ................................................................. 19-1 SRS .................................................................................................. 17-1
ECT and A/T Indicator (1KD-FTV, 2KD-FTV) ..................................... 8-1 Starting ............................................................................................... 2-1
ECT and A/T Indicator (2TR-FE) ........................................................ 7-1 Stop Light ......................................................................................... 12-3
Engine Control (1KD-FTV, 2KD-FTV) ................................................ 5-1 Taillight ............................................................................................. 13-1
Engine Control (2TR-FE) .................................................................... 4-1 Turn Signal and Hazard Warning Light ............................................ 11-1
Engine Control (5L-E) ......................................................................... 6-1 Wireless Door Lock Control (LHD) ................................................... 18-7
Engine Immobiliser System (1KD-FTV, 2KD-FTV) ........................... 5-13 Wireless Door Lock Control (RHD) ................................................... 19-7
Engine Immobiliser System (2TR-FE) .............................................. 4-13
Front Air Conditioner (2TR-FE, 1KD-FTV, 2KD-FTV) ...................... 30-1
HIACE (EM04Z2E)
Front Air Conditioner (5L-E) ............................................................. 31-1
Front Fog Light ................................................................................. 10-1

Front Wiper and Washer .................................................................. 24-1
Headlight ............................................................................................ 9-3
Headlight Beam Level Control .......................................................... 25-3
Horn .................................................................................................. 12-4
Ignition ................................................................................................ 3-1
Illumination ....................................................................................... 14-1
Interior Light ...................................................................................... 15-1
Key Reminder ................................................................................... 25-1
Light Auto Turn Off System ................................................................ 9-1
Light Reminder ................................................................................. 25-1
Multiplex Communication System (CAN) ....................................... 30-11
Option Connector (Parking Assist) ................................................... 34-3
Option Connector (TVSS) ................................................................. 34-1
Parking Assist (TOYOTA Parking Assist-Sensor) ............................ 26-1
Memo
HIACE (EM04Z2E) 341

1 HIACE (Cont. next page)
342
P o w e r S o u rc e
1 2 3 4
30A AM2 ∗ 1 : 2TR–FE
1 ∗ 2 : 1KD–FTV, 2KD–FTV, 5L–E
1 2 W–R W–R W–R
2 HB2 W–L
A
30A D. C. C 15A RADIO
1 2 1 2 L–Y
2
15A CIG
30A RR DOOR 10A DOME

5 7. 5A ACC
1 2 B–R 1 2 R ACC 3 R–B
2 2 2 5F
15A HEAD LH
W–L 2 AM1 IG1 4 B–Y B–Y
W
1 2 L B
40A HEAD 4
HEAD Relay ST1 1 R–W R–W
1 2 W–R W–R 1 2 R–W C
2 4 4
15A HEAD RH
4 15A IGN
10A ECU–B W–R 3 5 W–L 1 2 R W–R 7 AM2 IG2 6 B–R
4 4 4 4 5F
1 2 W–R ST2
2 10A MET IGN
10A ETCS H25

Ignition SW
1 2 Y–B
2
25A ABS SOL

RR CLR Relay
1 2 W–R 2 1
2
140A ALT 30A RR CLR 7. 5A A/C NO. 3
2
40A ABS MTR Y Y 5 3 L 1 2 P
1C 1 1 4 4
1 2 W
2 4
120A MAIN4
1
7. 5A ALT–S B–G B–G
1G D
1 2 P
2
50A FAN1 40A HTR
HIACE (EM04Z2E)
4 7. 5A A/C
2 1 7
25A PSD B–R B–R 5 3 L 3 4 L–O
1B 5L 5F
1 2 W
2 2 1 H34
50A FAN2 50A PTC1 Fuse Box
15A TVSS HTR Relay
1 2 L
2
30A FAN3 50A PTC2 15A A/F
W
1 2
FL MAIN
2. 0L 50A A/PUMP (∗1) 15A HAZ–HORN
80A GLOW (∗2)
1 2
1
W
1D
FL MAIN
3. 0W 20A EFI (∗1)
50A MAIN3 25A EFI (∗2)
3 1
W W 1 2
1B 1K
Battery
1 HIACE (Cont' d)
P o w e r S o u rc e
5 6 7 8
W–L
A
30A AM1 1
W–L
5F
T–LP Relay
1 10A TAIL
B–G
5G
B–Y 10A PANEL

B
R–W
C 30A PWR
PWR Relay
1 2
12
W–B
5E
30A DEF
DEF Relay
10A ELS 7
1 2 W–B
5M
15A FR FOG
R–W
30A DOOR
9 HB2
10A STOP
B–G 7. 5A OBD
D
15A RR FOG
HIACE (EM04Z2E)
R–W
15A RR HTR
Noise Filter
W–B
12
10A GAUGE
H41
Junction
Connector
7. 5A ECU–IG 1
5 3
3 25A WIP
B–Y 2 1
5F
W–B
IG1 Relay 20A WSH
7. 5A ST 15A RR WIP–WSH
R–W 1 2 B–W
4 4
10A A/C
W–B
W–B
H1 B3
M
343
2 HIACE
344
S ta rtin g C h a rg in g
1 2 3 4
(IG) (IG)
R–W R–W 10A 10A

MET IGN GAUGE
ACC 4
9 HB2
W–L 2 AM1 IG1 1 5M 2 5E
1
ST1 1 R–W
1 5F
7. 5A
L–R
ST B–R
Engine ECU
< 6–7>
7 AM2 IG2 6
2 Transmission IG+
30A ST2 8 R Control ECU< 8–4>
AM1
R
(∗3)
Charge
4
H25 12 HB2
H20
Combination
Meter
Ignition SW 19 CHG–
R 22 16 R
B–W
33
1 5G (∗3) (∗3)
R
(∗2 A/T, ∗14 A/T)
(∗3)
R
B–W
(∗15)
B34
B
R
(∗15) Junction
Connector
B–G
7 11
W–R
13
10 B–W 36 HB1
DB1
1 1G (∗15)
B34
Junction
Connector
1 HB2 4 4 9
B
(∗6, ∗14)
5 1 1
B–W
B–W
(∗15)
(∗15)
W
W–R
B
120A
(∗7)
ST
B36
Junction
Connector
MAIN4
Relay 3 DB3 2
P
1 1A 2 2
L–R
B
3 2
W
B–W (∗6, ∗14)

2 2 (∗4)
4 4
(∗5)
(∗4)
B–W
B–W
4 DB3 (∗1) 1 DB3 (∗15)

140A 7. 5A 30A R 4
Engine ECU
< 4–9> < 5–8>
5 DB3 (∗2, ∗14) 1 DB6 8 DB1 (∗3) 5 DB4

ALT ALT–S AM2
HIACE (EM04Z2E)
(∗4) 12 DB1 (∗3)
L B
B
W
1 1
B
P
B–W
W–B
(∗16)
7 DB3
P
L–R
N
D37
Park/Neutral
Position SW
1 1D 2 1 BE1 5
R
R
R
(∗4)
(∗15)
(∗15)
B34
W
W
Junction Connector 1 B 1 A 4 B 2 B
16 18 S B L IG
Option Connector
(TVSS ECU)< 34–1>
21 19 20
FL MAIN FL MAIN
3. 0W 2. 0L ∗ 1 : 2TR–FE M
1 A (∗1) ∗ 2 : 2KD–FTV
3 B B35
B
R
R
R
1 B (∗10) ∗ 3 : 5L–E
(∗8)
(∗15)
∗ 4 : 2TR–FE A/T, 1KD–FTV A/T, 2KD–FTV A/T Junction

B–R 1 C (∗9) Connector
∗ 5 : 2TR–FE M/T, 1KD–FTV M/T, 2KD–FTV M/T 2
1 D W W 8 9 W
(∗2 A/T, ∗14 A/T)
(∗11, ∗14) D5(A), D6(B) Engine ECU

(∗12) ∗ 6 : 2TR–FE, RHD 2KD–FTV DB3
1 E 1 G (∗1) Alternator (∗15) (∗15) (∗15) < 4–10> < 5–7>
∗ 7 : LHD 2KD–FTV, 5L–E
1 F (∗13) 1 H (∗2, ∗3, ∗14) 10
W

(∗3)
∗ 9 : 2KD–FTV A/T Cold Area Spec.

W
∗10 : 2KD–FTV A/T Except Cold Area Spec.

(∗15)
∗11 : 2KD–FTV M/T Except Cold Area Spec.

W–B
Battery
∗12 : 5L–E Cold Area Spec.
M ∗13 : 5L–E Except Cold Area Spec.
Engine ECU
< 4–10> < 5–8>
∗14 : 1KD–FTV
B3 A/C Amplifier
E1(A), (B), (C),
(D), (E), (F), E2(G), (H)
Starter
Combination Meter
< 28–3>
∗15 : ∗1, ∗2, ∗14

Transmission
Control ECU< 8–4>
< 30–7>
Engine ECU
< 6–6>
∗16 : w/ Option Connector (TVSS)

3 HIACE
Ig n itio n
1 2 3 4
B–R
ST2 1
D9
Noise Filter
(Ignition)
H25
B–R
B–R
B–R
B–R
Ignition SW
D20 D21 D22 D23
B–R
B–R
1 (No. 1) 1 (No. 2) 1 (No. 3) 1 (No. 4)
+B +B +B +B
17 HB2 4 DB1
IGT1 IGF GND IGT2 IGF GND IGT3 IGF GND IGT4 IGF GND
B–R
3 2 4 3 2 4 3 2 4 3 2 4
B–R
W–R
1 HB2
BR
BR
BR
BR
R–L
B–Y
Y–R
L–W
W–R
W–R
W–R
W–R
BR BR BR
W–R
BR
W–R W–R W–R

2
30A
AM2
HIACE (EM04Z2E)
W–R
7
1
D44
Junction
Connector
2 1
W
R–L
B–Y
Y–R
L–W
W–R
FL MAIN
2. 0L
Engine ECU
< 4–9>
Battery
BR
D1
M
345
346
E n g in e C o n tro l (2 T R – F E )
1 2 3 4
(BAT) (BAT) (BAT)
20A 15A 50A ∗ 8 : Algeria, Costa Rica, El Salvador, Guatemala, Honduras,
EFI A/F A/PUMP Mexico, Nicaragua, Niger, Panama, Peru, South Africa, Vietnam
7 AM2 IG2 6
∗12 : ∗1, ∗7 ∗8
ST2
2 2
B–R
W–R
H25 1 1E
Ignition SW
MAIN A/F
Relay Relay B–R
A
B–R
B
B–W
(∗12)
B–R
3 1J 2 1J 4 1J 1 1J 3 1I 2 1I 4 1I B12(B), B14(A)
C/OPN 1 A Air Injection Control Driver
Relay 26 HB2 BATT
B–R
B–R
B–R
G–Y
W–B
W–B
(∗12)
(∗12)
(∗12)
+B E W VP SIV DI SIP
B–R
5 B 1 B 6 B 2 A 3 B 2 B 4 B
8 1J 7 1J 6 1J
4 HB2 B–R
B
Y
LG
BR
L–Y
B–R
B–R
B–W
W–R
(∗12)
(∗12)
(∗12)
(∗12)
(∗12)
(∗12)
(∗12)
W–R
4 BP1
11 BD1 2 BD1 14 BD1 13 BD1 15 BD1
L
(∗12)
B–R
B–R
1 HB2
1 Ph1
B
Y
LG
BR
B–W
W–R
(∗12)
(∗12)
(∗12)
(∗12)
(∗12)
(∗12)
11 DB1
B–R
W–R
3 DB1 4 2
2
2
L
M M
(∗12)
Pump
B17
Air Pump
h2
Gage Assembly
D30
Air Switching
Valve
B–R
HIACE (EM04Z2E)
5 1
30A
W–B
AM2
BR
W–B
(∗12)
(∗12)
3 Ph1
3
1
4
W–B
D43
Junction Connector
2 W–R(∗12)
1 C
8 BP1
LG(∗12)
W
D
B–R
(∗12)
B–R
W–B
W–B
(∗12)
(∗12)
(∗12)
Y(∗12)
E
L–Y
W–B
FL MAIN F
2. 0L
B–R
G
B–R B–R B–R
H
G–Y
I
W–B
Battery W–B W–B L
J
(∗12) (∗12)
W–B
B2 D2 B2
4 HIACE (Cont' d) (Cont. next page)
5 B–R(∗5 ∗13) 6 7 8 B–R(∗5 ∗13)

A
(IG) B–R(∗5 ∗14) B–R(∗5 ∗14)
B
15A (IG) (BAT) ∗ 1 : Australia, Chile, China, Ecuador, Hong Kong, New Zealand, Thailand
IGN ∗ 2 : Costa Rica, Egypt, El Salvador, G. C. C. , Guatemala, Honduras, Malaysia, Nicaragua,
Panama, Peru, Russia, South Africa, Ukraine, Vietnam
1 5D
10A 10A ∗ 3 : Except ∗10
MET IGN ETCS ∗ 4 : Shielded
2 ∗ 7 : From Oct. 2006 Production
7 5C 9 5E 21 5E
∗ 8 : Algeria, Costa Rica, El Salvador, Guatemala, Honduras, Mexico, Nicaragua, Niger,
B–R Panama, Peru, South Africa, Vietnam
1 5M 2
A ∗ 9 : Egypt, G. C. C. , Russian
Stop Light
System< 12–4>
B–R B–R B–R ∗10 : ∗1, ∗2 ∗6, ∗7 ∗8, ∗7 ∗9
B ∗12 : ∗1, ∗7 ∗8
Check
Engine
∗13 : Except ∗14
B–R
B–R
B–R
B–R
B–R
B–R
B–R
IG+ EGW B1
H20
Combination Meter
3 1 Accelerator Position Sensor
6 32
1 1 1 1
1
B–R
G–R
Y–B
B2
Stop Lamp SW
4 2
D24
Fuel Injector
(No. 1)
D25
Fuel Injector
(No. 2)
D26
Fuel Injector
(No. 3)
D27
Fuel Injector
(No. 4)
21 HB1 VCP2 EPA2 VPA2 VCPA EPA VPA
2 2 2 2
D19
Camshaft Timing
Oil Control Valve
1 2 3 4 5 6 2
B
Y
R
R–L
B–R
B–W
L
B
W
R–L
B–Y
G–B
G–R
W–L
W–R
6 C 5 C 2 C 1 C 9 A 16 A 30 B 7 A 27 A 21 A 19 A 26 A 20 A 18 A 13 D 12 D
#1 #2 #3 #4 IGSW ST1– W +BM VCP2 EPA2 VPA2 VCPA EPA VPA OC1+ OC1–
B7(B), B9(A), D1(D), D3(C)
Engine ECU
AIRP AIDI AIRV FC BATT +B MREL PRG VG E2G THA RTHW THW E2 VTA2 VTA1 M+ M– GE01 VC VAF
11 D 20 C 24 D 25 A 3 A 1 A 8 A 23 C 28 C 30 C 29 C 31 C 32 D 28 D 19 D 20 D 5 D 4 D 8 D 18 D 25 D
Y–R
L–R
L–R
Y–G
Y
B
B
LG
(∗3)
L–Y
B–R
B–R
G–Y
W–R
(∗12)
(∗12)
(∗12)
(∗10)
L
1 DB1 2 DB1 8 DB1 9 DB1 17 DB1

(∗4)
L–B
Y–R
R–W
HIACE (EM04Z2E)
L–B
(∗3)
L–R
L–R
Y–R
Y–G
D44 4 6 2 1 2 3
1 2 2 Junction VTA2 VTA M+ M– VC VAF
(∗3)
L–B
10 AB1 11 AB1 19 AB1 20 AB1 2 Connector
9 11
L–R
Y–R
Y–G
W–R(∗12)
8 3
D28
VSV (Purge)
C 3 2 4 5 E2 VC E2
2
B29
Water Temp. Sensor
(Radiator)
D32
Water Temp. Sensor
(Engine Coolant)
LG(∗12) VG E2G THA E2 D29 D44 D31

D 1 1 3 5 10 1
Y–R
Throttle Body Junction Variable

Assembly Connector Resistor
Y–R
Y(∗12)
L
B–R
Y–R
+B
(∗10)
(∗3)
Y–R
L–Y A3 16 DB1
F 1
Air Flow Meter
B–R
B–R 5 DB1
B–R
G
Y–R
B–R B–R 3 AB1 Y–R Y–R Y–R Y–R Y–R

H C
(∗10)
G–Y
B–R
(∗10)
I
B–R
D
L L
J E
(∗12) (∗12)
M
347
348
B–R(∗5 ∗13) 9 10 11 12 B–R(∗5 ∗13)

A A
B–R(∗5 ∗14) B–R(∗5 ∗14)
B B

∗ 2 : Costa Rica, Egypt, El Salvador, G. C. C. , Guatemala, Honduras, Malaysia,
Nicaragua, Panama, Peru, Russia, South Africa, Ukraine, Vietnam
∗ 4 : Shielded
Combination Meter
< 28–4>
DLC3
< 29–3>
∗10 : ∗1, ∗2 ∗6, ∗7 ∗8, ∗7 ∗9
∗11 : ∗2 ∗6, ∗7 ∗9
∗12 : ∗1, ∗7 ∗8
∗13 : Except ∗14
B–Y
B–Y
Multiplex Communication System

(CAN)< 30–12>
14 6C 15 6C
ST Fuse
< 2–3>
Alternator
< 2–4>
Combination
Meter< 28–2>
Tail Fuse
< 13–2>
Airbag Sensor Assembly
Center< 17–2>
Park/Neutral Position SW (A/T)
< 2–2>
ST Fuse (M/T)
< 2–2>
Stop Lamp SW
< 12–3>
ELS Fuse
< 27–1>
Combination Meter
< 28–4>
Cooling Fan ECU No. 1< 29–2>
Ignition Coils
< 3–2> < 3–3> < 3–4>
DLC3< 29–3>
W
L–R
B–W
16 6C
12 DB1 6 DB3 27 HB1 57 HB1

B–Y
18 HB1
L
P
P–L
R–L
B–Y
Y–R
L–W
W–R
R–W
LG–B
W
L–R
B–W
B–Y
17 D 16 D 15 D 14 D 23 D 30 A 10 D 8 B 15 A 32 B 12 A 4 B 3 B 14 B 10 A 33 B 34 B 17 B 1 B
IGT1 IGT2 IGT3 IGT4 IGF1 NSW ALT SPD ELS F/PS STA STP ELS3 THWO RFC CANH CANL TC TACH
B7(B), B9(A), D1(D), D3(C)
Engine ECU
HT1A(∗11) OX1A(∗11)
PSW HT1B OX1B HA1A(∗12) A1A+(∗12) A1A– KNK1 EKNK E1 G2 NE– NE+ ME01 E04 EC E03 E01 E02
32 C 2 D 25 D 1 D 21 D 31 D 29 D 30 D 3 D 26 D 34 D 27 D 3 C 7 C 22 A 4 C 7 D 6 D
B
Y
BR
BR
BR
4
W–B
W–B
W–B
(∗10)
12 L
G
(∗1, ∗7 ∗8)
BR
(∗4)
HIACE (EM04Z2E)
B
G–W
Y
(∗12)
(∗12)
(∗4)(∗12)
5 D44
Junction
2 Dg1 1 Dg1 Connector
Y
1
(∗12)
(∗12)
(∗4)(∗12)
L
L
1 3
Y
B
Y
Y
Y
(∗4)
(∗4)
(∗11)
(∗11)
(∗12)
(∗4)(∗11)
HT1B OX1B
B
W
1 3 3 4
D16
Power Steering
Oil Pressure SW
HT1A OX1A A1A+ A1A– 2 2 1 13
+B E2 1 NE– NE
D35
(Bank 1 Sensor 2)
2 4
B36
Junction
Connector
12
E2 +B HA1A +B
D34
(Bank 1 Sensor 1)
D33
Air Fuel Ratio Sensor
(Bank 1 Sensor 1)
G–
4 2 1 2
D10
Camshaft
Position Sensor
D17
Crankshaft
Position Sensor
B–R
Y–R
(∗12)
(∗12)
2 3
g1
Knock Control
Sensor (Bank 1)
Y–R
B–R
(∗11)
(∗11)
(∗12)
(∗4)
(∗4)
Y–R B–R
BR
BR
BR
C
W–B
W–B
W–B
(∗10)
(∗10)
BR
(∗4)
(∗4)
(∗12)
(∗1, ∗7 ∗8)
10
B–R
D DB1 2 5 11 8 9
L 1 W–B
E
(∗12)
6 7 D43
(∗4)(∗11) Junction Connector
D2 D1 B2 D2
(∗4)
(∗12)
4 HIACE (Cont' d)
E n g in e Im m o b ilis e r S y s te m (2 T R – F E )
B–R(∗5 ∗13) 13 14 15 16
A
B–R(∗5 ∗14) (BAT)
B
10A ∗13 : Except ∗14
ECU–B ∗14 : RHD From Sep. 2007 Production
11 6C
2
2
13 6C
B–R
(∗5 ∗14)
H43
(∗5)
W–R
VC5 CODE TXCT AGND

1 17 5E
H46 1 4 5 7
Junction
Connector
3
2 5S
V
Y
GR
(∗5)
(∗5)
(∗5)
(∗5)
B–R
B–R
(∗5 ∗14)
(∗5 ∗13)
(∗5)
W–R
2 1 14 15 4 5
B7(B), B9(A), D1(D), D3(C) H44

Engine ECU Transponder Key ECU
IMI IMO EFII EFIO D IND KSW CTY GND

16 B 15 B 12 13 9 8 3 7 16
(∗5)
(∗5)
(∗5)
(∗5)
(∗5)
(∗5)
(∗5)
(∗5)
HIACE (EM04Z2E)
R–G
B–W
B–W
W–B
W–B
W–R
W–R
(∗5 ∗14)
(∗5 ∗13)
12 6C
15 HB1 52 HB1 2
H46
Junction
Connector
1
(∗5)
(∗5)
B–W
W–R
11 6C
W–B
W–B
(∗5 ∗14)
(∗5 ∗13)
DLC3< 29–4>
Combination
Meter< 28–6>
Unlock Warning
SW< 25–1>
Door Courtesy SW
(Front LH) (LHD)
< 15–6>
Door Courtesy SW
(Front RH) (RHD)
< 15–6>
1 5C
12 5E
(∗5)
W–B
B3
M
349
350
∗ 1 : 1KD–FTV
E n g in e C o n tro l (1 K D – F T V , 2 K D – F T V ) ∗ 2 : 2KD–FTV
∗ 3 : 2KD–FTV Wide Body
1 2 3 B–R 4 B–R(∗1)
A
(∗1)
(BAT) (BAT) L–B
B
B–R B–R Y–R Y–R Y–R Y–R Y–R Y–R
80A 25A C
GLOW EFI
(∗1)
B–R
Y–R
Y–R
D44
Junction 3 AB1 9 DB1
(∗2)
(∗1)
(∗2)
2
B–R
B–R
B–R
Connector 8 Y–R
(∗1)
(∗1)
A27 B–R
1 1E 4 DB3 5 DB1 8 DB3 Air Flow
Y–R
Y–R
Y–R
Meter 1 5
3 2
MAIN +B E2
(∗1)
B–R
Relay 20 AB1
BR
(∗2)
(∗2)
L–B
B–R
B–R
Y–R
Y–R
Y–R
B–R
B–W
(∗1, ∗3)
1 1J (∗1) E2G VG THA
(∗1)
2 3 4
B–R
(∗2)
Y–R
1 1 1
R
(∗1)
3 1J 2 1J 4 1J 2 A 3 A 1 B 2 B
(∗1)
(∗1)
B–R
B–R
B
(∗1)
(∗1)
B–L
B–R
B(∗1) RSC(∗1) VC E(∗1)
1 2 1 +B(∗2) E1(∗2) E2(∗2) 1
EDU Relay
VTA(∗1) 11 AB1 10 AB1 19 AB1
B–R
G–Y
DUTY
W–B
VAF(∗2)
D49
(Intake Manifold)
D46
Fuel Temp. Sensor
D32
Water Temp. Sensor
(Engine Coolant)
1 A 3 B D48(A), D50(B) 2 2 2
B
R
R
(∗1)
(∗1)
(∗2)
B–L
1 Throttle Body
D55
VRV (EGR)
D67
Swirl
Control Valve
D68
VSV (EGR Cut)
B37 Assembly
8 1J 7 1J 2 1 2
A2
(Air Cleaner)
Junction
Connector 11 DB1 10 DB1 8 DB1 2
G
2
B
R
W
(∗1)
(∗1)
R–L
R–L
Y–R
W–L
B
R
B–W
R–W
(∗1)
(∗1)
B–L
(∗1, ∗3)
B–R
G
R–L
B–W
15 A 2 B 9 C 15 D 18 C 4 C 29 C 20 D 28 D 29 D 19 D 32 C 24 C 31 D
GREL BATT EGR SCV EGRC LUSL VLU THIA E2 THF THW EVG VG THA
B7(B), B9(A), D1(D), D3(C)
1 1 Engine ECU
IREL +B MREL PRD INJF #1 #2 #3 #4
5 2 10 A 1 A 8 A 32 D 25 D 24 D 23 D 22 D 21 D
2 A (∗1) 1 A (∗1) 2 A (∗1) 1 A (∗1)
V
Y
(∗1)
R–L
Y–B
B–Y
B–R
B–R
G–Y
G–Y
G–R
1 B (∗2) 2 B (∗2) 1 B (∗2) 2 B (∗2) 1
GLOW Relay
3 1
HIACE (EM04Z2E)
1 1 BR
D24(A), (B)
Fuel Injector
(No. 1)
D27(A), (B)
Fuel Injector
(No. 4)
D25(A), (B)
Fuel Injector
(No. 2)
D26(A), (B)
Fuel Injector
(No. 3)
D64
Pressure
Discharge Valve
B–R 1 A (∗1) 2 A (∗1) 1 A (∗1) 2 A (∗1)

D
2
2 B (∗2) 1 B (∗2) 2 B (∗2) 1 B (∗2)

L
L
Y
Y
R
R
G
G
W
BR
(∗1)
(∗1)
B
W–R
W–B
2 BD1 17 BD1 15 BD1 6 BD1 16 BD1 7 BD1 13 BD1 14 BD1 10 BD1 3 BD1 5 BD1 12 BD1 11 BD1 4 BD1 8 BD1 18 BD1 9 BD1
Y
Y
R
R
14 DB1
2 3
3 2
B
W–B
B38
Junction
Connector
B39
Junction
Connector
B
Y
G
G
(∗1)
Y–B
B–Y
V–R
G–Y
G–R 1 1
L
W
BR
(∗1)
(∗1)
W–R
1
Y
6 C 5 E 1 D 6 E 2 E 1 E 3 E 5 C 1 C 4 C 4 D 2 C 2 D 3 C 3 D 4 E (∗1)
8 A 7 B 6 B 3 B 2 B 5 B 4 A 5 A 3 A 2 A 6 A 1 A 1 B (∗2)
+B PRD INJF # 10 # 20 # 30 # 40 INJ1 COM1 INJ4 INJ2 COM2 INJ3 COM3 PRV GND
D53
W–B
Glow Plug B13(A), B15(B), B40(C), B41(D), B42(E)
BR
E
B2
∗ 1 : 1KD–FTV
∗ 2 : 2KD–FTV
E n g in e C o n tro l (1 K D – F T V , 2 K D – F T V ) ∗ 5 : Except ∗6
B–R(∗1) 5 6 7 8 B–R(∗1)
A A
L–B L–B L–B L–B (IG) B–R(∗4 ∗5) B–R(∗4 ∗5)
B B
Y–R Y–R Y–R Y–R B–R(∗4 ∗6) B–R(∗4 ∗6)
C 15A C
IGN (IG)
Y–R
10A
MET
16 DB1 1 5D IGN
Combination
Meter
< 28–4>
DLC3
< 29–3>
H20
Combination Meter
L–B
L–B
L–B
L–R
Y–R
Y–R
Y–R
Y–R
9 5E 21 5E 1 5M
B–Y
B–Y
Stop Light
System< 12–4>
DLC3< 29–3>
4 A 2 A 6 A (∗1)
Stop Lamp SW
< 12–3>
Alternator
< 2–4>
ST Fuse
< 2–3>
Park/Neutral
Position SW (A/T)
< 2–2>
ST Fuse (M/T)
< 2–2>
Combination Meter
< 28–2>
Combination Meter
< 28–4>
1 1 3 2 1 1 B 3 B (∗2) 14 6C 15 6C
Glow
Check
Engine
B–R
B–R
B–R
E VC E2 PR2 VC 11
E2 VC
IG+ EGW L
D44
Junction
Connector
Y
PIM EGLS PR E2S VCS 3 1
W
9 6 32 25
D51
Turbo Pressure Sensor
D52
EGR Valve
Position Sensor
D45(B), D69(A)
Fuel Pressure Sensor
B–W
2 3 5 A 3 A 1 A (∗1) 16 6C
B29
Water Temp. Sensor (Radiator)
2 2 B (∗2)
B–R
G–R
B–W
6 DB3 12 DB1 57 HB1
B–Y
R
P–L
R–W
21 HB1 60 HB1
B2
Stop Lamp SW
4 2 18 HB1
P
P
P
P
G
W
(∗1)
(∗1)
(∗1)
L–B
L–R
G–B
G–R
W
Y
B–W
R–L
B–R
G–R
B–W
B–Y
20 A 28 C 33 C 26 D 1 C 2 C 33 D 18 D 9 A 14 B 12 A 14 A 15 B 8 D 6 A 7 A 17 B 2 A 18 A 11 A 4 A
RTHW PIM EGLS PCR1 E2S VCS PCR2 VC IGSW ST1– W GIND STP ALT NSW STA SPD THWO SIL TC TACH
B7(B), B9(A), D1(D), D3(C)
Engine ECU
G+(∗1)
E1 G1(∗2) G– NE+ NE– PCV+ PCV– VCP2 EPA2 VPA2 VCPA EPA VPA E02 E01 EC RFC RFC2 FAN WFSE
7 C 23 C 31 C 27 D 34 D 2 D 1 D 27 A 29 A 23 A 26 A 28 A 22 A 6 D 7 D 6 B 12 D 11 D 13 D 19 A
(∗2)
P–L
L–R
W–L
LG–B
P
B
W
BR
BR
R–L
Y–R
W–L
R
W–B
G
W–R
BR
R(∗1)
Y(∗2)
G(∗1)
L(∗2)
(Shielded)
(Shielded)
3 DB2 8 DB2 17 DB1 7 HB4
HIACE (EM04Z2E)
BR
D
1 1 2 1 1 2 3 4 5 6
(∗2)
P–L
L–R
W–L
LG–B
NE NE– VCP2 EPA2 VPA2 VCPA EPA VPA

13
G–
D10
Camshaft
Position Sensor
D17
Crankshaft
Position Sensor
D47
Suction
Control Valve
B36
Junction
Connector
2 3 2 12
BR
W–B
FAN3 Relay
< 29–2>
DLC3< 29–3>
Cooling Fan
ECU No. 1< 29–1>
Cooling Fan
ECU No. 2< 29–2>
B1
BR BR
BR
BR
D
(∗1) (∗1)
(Shielded)
(Shielded)
BR BR
2 11 3 5 13 7 E
(∗1) (∗1)
4 1 D43
BR
BR
W–B
Junction Connector
BR BR
BR
BR
E
D3 B2
M
351
352
∗ 1 : 1KD–FTV
E n g in e C o n tro l (1 K D – F T V , 2 K D – F T V ) ∗ 5 : Except ∗6
B–R(∗1) 9 10 11 12
A
B–R(∗4 ∗5) B–R(∗4 ∗5)
B A
B–R(∗4 ∗6) B–R(∗4 ∗6)
C B
O3(A)
Transmission
Control ECU
D65(A), D66(B)
Turbocharger Variable Nozzle Motor Assembly
CAN+ CAN–
21 A 20 A VTA2 VTA1 E2S VCS VNE2 VNVC M– M+
4 B 1 B 5 B 6 B 2 B 3 B 1 A 2 A
L
W
L
Y
R
R
G
G
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
Y–L
R–W
(Shielded)
8 DO2 16 DO2 (∗1)
9 DO1 19 DO1 (∗2) 11 DB7 12 DB7 2 DB7 3 DB7 7 DB7 8 DB7 6 DB7 5 DB7 4 DB7
L
W
L
Y
R
R
G
G
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
(∗1)
Y–L
B–R
R–W
1 DB2 6 DB2
(Shielded)
3 10 9 11 6 8 1 5 12
+B VTA2 VTA1 E2S VCS VNE2 VNVC M– M+
L
W
B7(B), B9(A), D1(D), D3(C)
22 B 21 B Engine ECU VNTO VNTI GND
CAN+ CAN– B43 7 2 4
Turbo Motor Driver
CANL CANH IMI IMO VNTI VNTO

BR
BR
(∗1)
(∗1)
(∗1)
(∗1)
Y–B
Y–G
23 B 24 B 30 B 29 B 17 D 10 D
14 DB7 15 DB7 9 DB7 13 DB7
(∗4)
(∗4)
(∗1)
(∗1)
Y–B
Y–G
B–W
W–R
BR
BR
(∗1)
(∗1)
(∗1)
(∗1)
Y–B
Y–G
HIACE (EM04Z2E)
15 HB1 52 HB1
(∗4)
(∗4)
B–W
W–R

(CAN)< 30–12>
BR
D
(∗1)
BR
E
(∗1)
W–R(∗4)
C
B–W(∗4)
D
5 HIACE (Cont' d)

E n g in e Im m o b ilis e r S y s te m (1 K D – F T V , 2 K D – F T V ) ∗ 5 : Except ∗6
13 14 15 16
B–R(∗4 ∗5) (BAT)
A
B–R(∗4 ∗6)
B 10A
ECU–B
11 6C
H43
13 6C 2 Transponder Key Amplifier
B–R
(∗4 ∗6)
(∗4)
W–R
VC5 CODE TXCT AGND
1
H46 1 4 5 7
Junction 17 5E
Connector
3
2 5S
V
Y
GR
(∗4)
(∗4)
(∗4)
(∗4)
B–R
B–R
(∗4 ∗6)
(∗4 ∗5)
(∗4)
W–R
2 1 14 15 4 5
H44
Transponder Key ECU
EFII EFIO D IND KSW CTY GND

12 13 9 8 3 7 16
(∗4)
(∗4)
B–W
W–R
W–B
W–B
(∗4 ∗5)
(∗4 ∗6)
HIACE (EM04Z2E)
Y
W
(∗4)
(∗4)
(∗4)
(∗4)
R–G
12 6C
2
H46
Junction
Connector
1
11 6C
W–B
W–B
(∗4 ∗5)
(∗4 ∗6)
DLC3< 29–4>
Combination
Meter< 28–6>
Unlock Warning
SW< 25–1>
1 5C
Door Courtesy SW
(Front RH)< 15–6>
12 5E
W–R(∗4)
C
B–W(∗4)
D
(∗4)
W–B
B3
M
353
354
E n g in e C o n tro l (5 L – E )
1 2 3 4
(BAT) (BAT) (IG) (IG)
80A 25A 15A 10A L–B

GLOW EFI IGN MET IGN A
Y–R
H20 B
2
Combination Meter
6 DB1 1 DB1
1 1E 1 5M
9 5E 21 5E
Stop Light
System< 12–4>
MAIN
L–B
Y–R
Relay
Glow
Check
Engine
B–W
B1
B–R
B–R
B–R
Accelerator
Position Sensor 1 2
IG+ EGW L VCP2 EPA2
3 1J 2 1J 4 1J 1 1J 3 1
6 32 25
B–R
G–R
VPA2 VCPA EPA VPA
B–W
B–R
G–Y
W–B
3 4 5 6
B2
Stop Lamp SW
4 2
21 HB1 60 HB1
B–W
L
G
W
R–L
B–R
B–R
W–L
G–R
B–W
1 1
2 E 1 E 14 E 11 F 5 E 1 F 12 F 6 F 4 F 5 F
SREL BATT IGSW ST1– W GIND VPA2 VCPA EPA VPA
5 2
B8(F), B10(E), D2(H), D4(G)
Engine ECU
GLOW
Relay
+B TCV LU–B LU+B LU–A LU+A MREL DATA CLK NE+ NE– TDC+ TDC– E1 THOP E01 E02
3 1 12 E 11 H 7 H 8 H 9 H 10 H 3 E 6 G 14 G 19 H 18 H 17 H 16 H 14 H 15 G 13 H 26 H
1 1
G
W
B–R
G–Y
B–W
L
L
L
Y
Y
R
G
BR
BR
BR
HIACE (EM04Z2E)
B
(Shielded)
(Shielded)
(Shielded)
W–B
2 1 3 4 6 1 4 2 1 2
14 DB1 LU–B LU+B LU–A LU+A DATA CLK
+B1 +B2 E1
D61
Timer Control Valve
D60
Injection Pump
Assembly
D63
Throttle
Position SW
1 2 5 D58 2 1 2 1
D18
Engine
Speed Sensor
D62
Crankshaft
Position Sensor
B
W–B
Throttle Body
Assembly
B–R
B–R
B–R
1 W–B
BR
BR
5 DB1 3 DB1 4 DB1

(Shielded)
(Shielded)
(Shielded)
BR
2 6 4 11 5
B–R
B–R
B–R
B–R
D54 3
W–B
Glow Plug
B–R B–R B–R B–R D43 1
BR
BR
Junction Connector
BR
B2 D4
355 HIACE (EM04Z2E)
B
A
L–B
Y–R
1
2
2
1
B R Y–R
12 H
5 G
THF
SPV+
D59
Spill Control Valve D46
Fuel Temp. Sensor
Y–R
2
1
B–L R–W Y–R

25 H
4 G
THW
SPV–
6 HIACE (Cont' d)
D32
5
Water Temp. Sensor

Y–R
R–B (Engine Coolant)

2 F
AC1
A/C Amplifier Y–R Y–R

9 G
E2
< 31–2> < 31–3>

G–W
8 F
ACT
R–L R–L R–L

3 G
19 AB1
7 DB1
THA
Cooling Fan ECU No. 1< 29–2> LG–B

7 E
RFC

1
2
Y–R
Y–R
20 AB1
FAN3 Relay W–L

13 E
FAN
< 29–2>
A2
(Air Cleaner)
Combination Meter Y Y
8 E
57 HB1
< 28–4> Y–R Y–R

THWO
2 DB1
H41 I12(A), I13(B)

Junction Junction
Engine ECU
Connector Connector
1
13
Y–R

7 A
7 B
H1
2
1
P Y–R
E
2 G
PIM
PIM
17 IH3 (LHD)
17 IH4 (RHD)
B8(F), B10(E), D2(H), D4(G)
6
3
Y–R
L–B L–B
1 G
VC
VC
4
3
W–B L–W L–W L–W

20 E
6 IH2
14 HB2
HSW
D57
L–B
I6 Manifold Absolute
Idle–Up SW Pressure Sensor
Alternator W W
22 E
ALT
13 DB1
< 2–3>
2
1
L–R L–R Y–R

12 G
3
2
17 DB1
16 DB1
W–B Y–G Y–G Y–G

RTHW
8 G
A1
17 AB1
11 DB1
PR2
B29
A5 Water Temp. Sensor
Pressure SW (Radiator)
E n g in e C o n tro l (5 L – E )
B–Y Combination
14 6C
Meter
< 28–4>
B–Y B–Y B–Y DLC3
7 F
16 6C
15 6C
18 HB1
< 29–3>
TACH
7
P–L Combination Meter

9 E
SPD
< 28–2>
P R–W Stop Lamp SW
4 E
19 E
TC
STP < 12–3>
DLC3< 29–3>
W R ST Fuse
15 E
11 E
SIL
STA
< 2–2>
8
M
356
E C T a n d A /T In d ic a to r (2 T R – F E )
1 2 3 4
(BAT) (IG) (BAT)
20A 15A 10A

EFI IGN ETCS
2 2
9 5E
∗ 2 : Costa Rica, Egypt, El Salvador, G. C. C. , Guatemala, Honduras,
2
Malaysia, Nicaragua, Panama, Peru, Russia, South Africa, Ukraine, Vietnam
MAIN ∗ 4 : From Oct. 2006 Production
Relay
∗ 5 : Algeria, Costa Rica, El Salvador, Guatemala, Honduras, Mexico, Nicaragua, Niger,
Panama, Peru, South Africa, Vietnam
B–R
Y–B
∗ 7 : ∗1, ∗4 ∗5, ∗2 ∗3, ∗4 ∗6
(CAN)< 30–12>
3 1J 2 1J 4 1J 1 1J
B–R
B–R
G–Y
W–B
Engine Control System
< 4–6> < 4–7> < 4–8> < 4–10> < 4–12>
Y–B
B–R
9 A 7 A 27 A 21 A 19 A 26 A 20 A 18 A 8 B 4 B 17 B 28 C 30 C 29 C 32 D 19 D 20 D 5 D 4 D 8 D 18 D 33 B 34 B
IGSW +BM VCP2 EPA2 VPA2 VCPA EPA VPA SPD STP TC VG E2G THA THW VTA2 VTA1 M+ M– GE01 VC CANH CANL
B7(B), B9(A), D1(D), D3(C)
Engine ECU
BATT +B MREL E1 ME01 E04 EC E03 E01 E02 SLT+ SLT– SL S1 S2
3 A 1 A 8 A 3 D 3 C 7 C 22 A 4 C 7 D 6 D 12 C 13 C 11 C 9 C 8 C
BR
BR
BR
BR
(∗7)
B–R
B–R
G–Y
W–B
W–B
W–B
(∗1, ∗4 ∗5)
L
LG
GR
P–L
HIACE (EM04Z2E)
W–L
2 6 7 4 8
SLT+ SLT– SL S1 S2
11 13
Y
B
O
G
W
D43
Junction
Connector
B36
Junction
Connector
1 12
D41
BR
BR
BR
(∗7)
W–B
W–B
W–B
W–B
ECT Solenoid
(∗1, ∗4 ∗5)
W–B
B2 D2 D1 B2 D2
7 HIACE (Cont' d)

E C T a n d A /T In d ic a to r (2 T R – F E ) until Apr. 2009 Production
5 6 7 8
(IG) L–R
10A D37
GAUGE
RB
2 5E
PL RL NL DL 2L LL
6 1 9 7 3 8
L–R
L
Y
R
GR
R–Y
R–W
Y–R
1 1 1 5 DB4
8 DB5 1 DB4 4 DB5 6 DB5 5 DB5 1 DB5
8 L–R
D42
Transmission
Revolution Sensor
(Output)
D40
Transmission
Revolution Sensor
(Input)
D44
Junction
Connector
2 2 2
D39
A/T Fluid Temp.
Sensor
2
L
L
Y
Y
R
R
GR
R–Y
4 14 12 3 1
G
Y–R
B–W
19 5E 1 5E
B34
Junction
Connector
B35
Junction
Connector
R
5 13 2
Y
R
R–W
GR
R–Y
35 C 27 C 34 C 26 C 22 D 28 D 9 B 10 B 11 B 11 5D
SP2+ SP2– NCO+ NCO– THOC E2 L 2 R
48 HB1 25 HB1 26 HB1 17 HB1 33 HB1
B7(B), B9(A), D1(D), D3(C)
Engine ECU
R–Y
3
Y
R
19 B
Clearance Warning
ECU< 26–4>
(∗9)
G–Y
L
GR
(∗8)
G–Y
R–W
< 33–6>
HIACE (EM04Z2E)
15 12
R–W
R–W
(∗8)
R–Y
G–Y
2 6D 4 6D 1 6D
2 HH1
H42
Junction
Connector
9 2
17 14
19 HB2 NSSD ATD
(∗9)
G–Y
3 6D
L
GR
(∗8)
G–Y
B
Y
R
B
R–W
Transmission
Control SW
1 24 23 22 21 2 3
AT3
3 P R N D 2 L
H22
3
B
B
3
2
L
P
R
N
D
11 6E 13 6E
E1
12 6E H20 7
1
Combination Meter W–B W–B
HH1
(∗8) (∗8)
W–B
(∗9)
H2
M
357
358
E C T a n d A /T In d ic a to r (1 K D – F T V , 2 K D – F T V ) ∗ 1 : 1KD–FTV
∗ 2 : 2KD–FTV
1 2 3 4
(BAT) (IG)
25A 15A
EFI IGN
9 5E 7 5C
MAIN
Relay B–R
B–R
1 1J B–R
B–R
3 1J 2 1J 4 1J
B–R
3 DB1 (∗1) 26 HB2
1 DB1 (∗2)
B–R
L
W
B–R
L
G–Y
1
W–B
W
B–R
B–R
< 5–3> < 5–4> < 5–6> < 5–7> < 5–8>
3
1 DB2 6 DB2 16 DO2 8 DO2 17 DO2 (∗1)
B37
Junction
Connector
2 19 DO1 9 DO1 11 DO1 (∗2) 2 OB1
B–R
L
W
L
B–R
B–R
B–R
2 B 9 A 4 C 29 C 28 D 19 D 18 D 15 B 17 B 27 A 29 A 23 A 26 A 28 A 22 A 18 A 11 A 19 A 22 B 21 B
BATT IGSW LUSL VLU E2 THW VC STP SPD VCP2 EPA2 VPA2 VCPA EPA VPA SIL TC WFSE CAN+ CAN–
20 A 21 A 5 A 6 A
B7(B), B9(A), D1(D), D3(C)
Engine ECU CAN– CAN+ +B IG2
+B MREL EC E02 E01 E1 EVG VG THA THF CANL CANH O1(C), O2(B), O3(A)
1 A 8 A 6 B 6 D 7 D 7 C 32 C 24 C 31 D 29 D 23 B 24 B
E01 E1 NSW STA STP SPD1
10 C 1 C 12 C 11 C 14 A 25 A
B–R
G–Y
W–B
BR
BR
BR
R
BR
BR
P–L
B–W
R–W
HIACE (EM04Z2E)
25 DO2 9 DO2 (∗1) 4 OB1 5 OB1 19 DO2 2 DO2 (∗1)
20 DO1 10 DO1 (∗2) 1 DO1 2 DO1 (∗2)
BR
BR
P–L
R–W
13
5 DB2 4 DB2
< 5–3> < 5–4>
B36
Junction
Connector
W–B
12
(CAN)< 30–12>
R
P–L
W–B W–B
B–W
R–W
BR
ST Fuse
< 2–3>
11
6 BR
Stop Lamp SW
< 12–3>
D43
Junction
Connector
Combination Meter
< 28–2>
BR
BR
< 2–2>
BR
W–B
BR
B2 D3 D3
8 HIACE (Cont' d)
∗ 1 : 1KD–FTV
∗ 2 : 2KD–FTV
∗ 3 : Before Oct. 2006 Production, RHD From Oct. 2006 Production,
E C T a n d A /T In d ic a to r (1 K D – F T V , 2 K D – F T V ) until Apr. 2009 Production
5 6 7 8
(IG) L–R
10A D37
GAUGE
RB
Y–B
(∗1) 2 5E
PL RL NL DL 2L LL
6 1 9 7 3 8
L–R
2 2 1
L
Y
R
GR
R–Y
R–W
Y–B
5 DB4
8 DB5 1 DB4 4 DB5 6 DB5 5 DB5 1 DB5
L–R
D42
Transmission
Revolution Sensor
(Output)
D40
Transmission
Revolution Sensor
(Input)
1 1
D56
A/T Fluid Temp.
Sensor
3 3 2
R R R
2 DO1 DO2 DB2
4 4 7
Y (∗2) (∗1) Y Y
L
L
R
G
DO1 DO2 DB2
(∗2) (∗1) 6
R–Y R–Y
Y
Y
R
R
7 DO2 15 DO2 6 DO2 14 DO2 18 DO2 1 DO2 (∗1)

R–Y
OB1
8 DO1 18 DO1 7 DO1 17 DO1 5 DO1 15 DO1 (∗2)
3
L
L L 6 4 14 12 3 1
OB1
B35
Junction
Connector
L
L
L
Y
Y
R
R
G
Y–B
R–Y
19 5E 1 5E 5 13 2
B34
Junction
Connector
Y
R
R–W
GR
R–Y
30 C 29 C 3 C 2 C 24 C 23 C 10 B 11 B 8 B 9 B
SP2+ SP2– NCO+ NCO– THOC E2 L 2 D R
48 HB1 11 5D 25 HB1 26 HB1 17 HB1 33 HB1
O1(C), O2(B), O3(A)
R–Y
SLT+ SLT– SL S1 S2 THO 3
Y
R
20 C 19 C 16 C 18 C 17 C 25 C 12 B
R–W
R–W
(∗4)
G–Y
L
LG
GR
GR
GR
(∗1)
(∗3)
L–B
P–L
G–Y
W–L
B
HIACE (EM04Z2E)
15 12
(∗3)
(∗4)
R–Y
G–Y
G–Y
1 OB1 2 6D 1 6D
5 DO2 13 DO2 24 DO2 10 DO2 11 DO2 (∗1) 12 DO2 Diode 2 HH1
H42
Junction
Connector
6 DO1 16 DO1 14 DO1 12 DO1 13 DO1 (∗2) 9 2 (Power Side Door) 17 14

< 33–6>
NSSD ATD
B
3 6D
L
LG
GR
GR
GR
(∗1)
(∗1)
(∗3)
L–B
P–L
Y–B
G–Y
W–L
Y
R
19 HB2
R–W
Transmission
Control SW
2 6 7 4 8 1 5 1 24 23 22 21 2 3
AT3
SLT+ SLT– SL S1 S2 OT+ OT– 3 P R N D 2 L
H22
B
3
Y
B
B
B
O
G
W
3
2
L
P
R
N
D
11 6E 13 6E
E1
12 6E H20 7
1
Combination Meter W–B W–B
HH1
(∗3) (∗3)
D41 W–B
ECT Solenoid (∗4)
H2
M
359
9 HIACE
360
A u to m a tic L ig h t C o n tro l a n d
H e a d lig h t
L ig h t A u to T u rn O ff S y s te m
1 2 3 4
(BAT) (IG) (BAT)
10A 7. 5A 40A
ECU–B ECU–IG HEAD
W–L
2 2 4
2 2
1 1
R–Y
R–Y
W–R
15A 15A
A/C Amplifier
< 30–7>
Rear Fog Lamp SW
< 10–3>
W–R
H7(A) HEAD HEAD
5 Integration Relay 14 A 2 2 LH RH
SIG HRLY W–R
W–R
2 2
Control No. 1)
H39
Diode
(Automatic Light
H38
Diode
(Headlight)
1 1 4 4
3
ECUB GND DCTY CLTB CLTE CLTS TRLY AUTO 4 4
HB2
6 1 26 26 A 24 A 25 A 19 10 A
R–B
R–B
R–B
R–B
1 3
R–W
R–W
L
R
P
B
W
6 6E 5 6E 8 6E 7 6E 3 6E 1 6E
17 5E 12 5E 7 5M 27 5E 3 5H
HEAD
Relay
8 AB1 9 AB1
2 5
R
L
R
W–B
W–B
W–R
3 IH2 14 IH2 4 IH2
4 6E 2 6E
2 4 4 3 3
P
B
W
O(∗3)
W–L
R–W
Control No. 2)
H40
Diode
(Automatic Light
A19
Headlamp (LH)
A7
Headlamp (RH)
R–B
R–B
R–B
R–B
BE(∗4)
R–W
1 1 2 1 2
1 3 4
CLTB CLTE CLTS 18 5H
R–G
Interior Light System

< 15–5>
12 A 13 A 8 A 17 A (LHD)
R–L
R–L
R–B
R–B
13 B 14 B 1 B 10 B (RHD)
A EL H T HF HU HL
I10 16 5B
Automatic Light
Control Sensor OFF R–B
HIACE (EM04Z2E)
Tail R–B
T–LP Relay
< 13–1>
Head
Light
Control SW
38
AUTO
W–B
+
Low
12 High
Dimmer SW
High Beam
Flash E1
H41
Junction
Connector
H20
Combination
Meter
1 H28(A), H29(B) 16 A 7 A (LHD) 7

Combination SW 9 B 2 B (RHD)
(∗1)
W–B
R–L
W–B

7 6F
1 HH1
R–L
(∗2)
W–B
17 35
∗ 4 : From Apr. 2009 Production R–L R–L R–L
W–B
W–B
5H 5B
1 6F
(∗1)
W–B
W–B
B3 H1 H2
10 HIACE
F ro n t F o g L ig h t R e a r F o g L ig h t
1 2 3 4
(BAT) (BAT)
15A 15A
FR FOG RR FOG
∗ 2 : Except ∗1
4 5M 8 5M
L
TAIL Fuse
R–Y
24 HB2 < 13–1>
H42 4 BT2
Junction
R
Connector
L
G
G–R 19 22 G–B 16 HB2
4 4 20
G
R–Y
G–B
3 1
Illumination System
< 14–2>
9 IH2 20 IH2 10 IH2
FR FOG 1 A (∗2)
G–R
Relay 1 B (∗1)
G–B
R–Y
G–R
5 2
49 HB1 7 A (∗2) T14(A), T15(B) 6 A (∗2)
7 3 4 8 3 B (∗1) Junction 2 B (∗1)
4 4 Connector
FS ILL+ B L
11 A (LHD)
G–R
12 B (RHD)
Y
V
G–R
BFG LFG E LH
Off 1 6 I3
16 AB1 Front Fog Rear Fog Lamp SW 3 TU1
R–Y
Light SW
On
R–B
Y
W–B
H28(A), H29(B) 10 A (LHD)
V
Y Combination SW 16 B (RHD)
HIACE (EM04Z2E)
9 B 19 IH2
2 2
Y
Y
W–B
I12(A), I13(B)
Junction
Connector
R–B
Rear
Fog
Rear
Fog
2 CA1 1 HA2 7 A
U1
Rear Combination
Lamp (RH)
T16
Rear Combination
Lamp (LH)
6 6
Y
Y
Y
W–B
30 GR
Y
W
W–B
W
FOG
1 1
17 IH3
Combination SW
< 9–3>
9 ZU1
Front Fog
C2
Fog Lamp
(Front LH)
C4
Fog Lamp
(Front RH)
E1 6 6F 3 TU2 (∗2)
2 2
H20
Combination
Meter
1 3 2 3 TU3 (∗1) 4 TY2
7
W–B
W–B
W–B
W–B
(∗3)
13
W–B
W–B
U2
1 6F Junction
W–B
9 Za1 Connector
H41
Junction
Connector
(∗4)
W–B
5 CA1 1 HH1 1 5 TY2
W
W–B
W–B W–B
(∗3)
W–B
W–B
W–B
W–B
A1 H2 H1 a1 Y1
M
361
11 HIACE
362
T u rn S ig n a l a n d H a z a rd W a rn in g L ig h t
1 2 3 4
(BAT) (IG)
10A ∗ 2 : LHD From Oct. 2006 Production, RHD From Apr. 2009 Production
GAUGE ∗ 3 : Standard Body Standard Roof
15A
HAZ–HORN
∗ 4 : Except ∗3
∗ 5 : w/ Option Connector (TVSS)
2
5 1I 1
IG
Flasher Relay
L
+B GND EHW EL ER LL LR
4 7 8 5 6 3 2
Integration
13 HB2 Relay< 18–7> < 19–7>
L
1 5J 12 5E 7 5M 17 5S 11 5S 12 5S 13 5S 16 5S 14 5B 31 5B 15 5A 27 5A
L
L
L–R
G
W–B
W–B
Y
G–W
(LHD)
4 TU1
L
L–R
G–B
G–Y
L
L
(∗5)
(∗5)
L–R
L–R
G–W
1 IH2
(RHD)
Y
G–W
(LHD)
1 A 3 A (LHD) Option Connector
(TVSS ECU)
6 B 8 B (RHD) < 34–3>
4 4
TL TB TR 31 26
3 3
LH B B
Turn
Turn
HIACE (EM04Z2E)
U1
Rear Combination
Lamp (RH)
T16
Rear Combination
Lamp (LH)
Off
Turn
Signal SW
Turn LH
Turn RH
6 6
2 2
H9
Hazard Warning
Signal SW
I4
Hazard Warning
Signal SW
RH
4 4
W
H28(A), H29(B) 2 A (LHD) E1

H20
Combination Meter
A23
Turn Signal Lamp
(Front LH)
A1
Turn Signal Lamp
(Front RH)
Combination SW 7 B (RHD) 7 1 1
W–B
(LHD)
7 B
W–B
W
(∗1)
W–B
W–B
W–B
I12(A), I13(B)
Junction
Connector
W–B
W–B
7 A
(RHD)
GR
W
GR
(∗2)
W–B
W–B
5 6F
W–B
3 TU2 (∗4)
(LHD)
9 ZU1 1 3 2 3 TU3 (∗3) 4 TY2
17 IH3 1 HH1
1 6F U2
8
W–B
W–B
W–B
Junction Connector
(∗1)
12 13 W–B
W–B
(LHD) 9 Za1 5 TY2

W
W–B
1 H41
W–B
W–B
Junction
Connector
W–B
W–B
W–B
B3 H1 H2 A1 a1 Y1
12 HIACE
B a c k – U p L ig h t S to p L ig h t H o rn
1 2 3 4
(IG) (BAT) (BAT)
10A 10A 15A

GAUGE STOP HAZ–HORN
∗ 1 : w/ Rear Wiper
∗ 2 : w/o Rear Wiper
∗ 3 : Standard Body Standard Roof 2
∗ 4 : Except ∗3
2 5E 4 5A 24 5A 6 5E 2 5B 18 5S 4 5J 3 5J
∗ 6 : w/ Option Connector (TVSS)
∗ 7 : w/ Option Connector (Clearance Warning ECU)
L–R
L
O
G–B
R–W
R–W
G–W
G–W
5 DB4 1 6A
19 17 HB4
L–R 21 HORN
(A/T) T14(A), T15(B) 8 A (∗4) Relay
B35
Junction
Connector
Junction Connector 8 B (∗3) 20
L–R
G–B
(M/T)
3 6A

< 26–3>
2 2
(∗5)
2
R–W
R–W
G–W
9 A 10 A 2 A 11 A 3 A (∗4)
G–W
9 B 10 B 6 B 11 B 7 B (∗3) 7 1I 8 1I
RB RL
D36
Back–Up Lamp SW
B2
Stop Lamp SW
L
P
R
1 1
D37
Park/Neutral
Position SW
L
1
Y
18
BR
L–B
R–W
L
B
(M/T)
H42
Junction
Connector
R
L
15
P
P
(∗7)
(A/T) 19 HB4
Skid Control ECU
with Actuator
< 16–2>
Taillight System
< 13–3>
Transmission
Control ECU< 8–4>
2 TU1 8 TU1 8 HB4 18 AB1
L
Engine ECU
< 4–10> < 5–7> < 6–7>
< 21–4>
1 DB4 3 dT1
Taillight
System
< 13–4>
R–W
BR
L–B
L
L
Y
11 5D 3 5A
1 3 5
B
1
1 3 5 B
Y
Y
(∗6)
Tail
d1
Center
Stop Lamp
Stop
Back–Up
HIACE (EM04Z2E)
1 5E 2
15 5C
Tail
Stop
Back–Up
Option Connector
< 34–4>
1 1
L
L
U1
Rear Combination
Lamp (RH)
6
A15
Horn (Low)
A16
Horn (High)
B
W
(∗1)
(∗2)
6 T16 12 5H
W
Rear Combination
Lamp (LH)
1 dT1 2 dT1
Y
GR
1
W–B
GR
W–B
Option Connector
(TVSS ECU)
< 34–2>
BR
(∗1)
(∗2)
W–B
3 TU2 (∗4)
9 ZU1 1 3 2 3 TU3 (∗3) 4 TY2 HO
U2
Horn SW
W–B
W–B
Junction Connector 3 TY1 3 TY2
9 Za1 5 TY2
H31
Spiral Cable
W
BR
(∗1)
(∗2)
W–B
W–B
W–B
a1 Y1 Y1
M
363
13 HIACE
364
T a illig h t
1 2 3 4
(BAT) ∗ 1 : Except ∗2 ∗ 4 : Before Oct. 2006 Production, RHD From Oct. 2006 Production (IG)
∗ 2 : Standard Body Standard Roof until Apr. 2009 Production
∗ 3 : w/ Automatic Light Control System ∗ 5 : LHD From Oct. 2006 Production, RHD From Apr. 2009 Production
120A 10A
MAIN4 MET IGN
1 1G 1 5M
LG
B–G
G
LG
BR
T14(A), T15(B) 4 A (∗1)
1 5G 6 5Q 12 5A 19 5A
G
B–R
12 A 5 A (∗1)
12 B 5 B (∗2)
Y
10 6
T–LP
Relay
10A TAIL
ILL+ IG+
10A PANEL
9 TU1
Tail
Integration Relay
< 9–2>
Y
9 5S 4 5E 15 5B
7 TU1
(∗3)
R–G
R–G
G
G
Stop Light System
< 12–2>
Stop Light System
< 12–2>
6 ZU1 E1
BR
H20 7
B
15
Y
H42 3 5 3 5
1
B35
Junction
Connector
Junction 17 16
Connector 6 Za1
Tail
Tail
Stop
Stop
HIACE (EM04Z2E)
R–G
G
G
U1
Rear Combination
Lamp (RH)
T16
Rear Combination
Lamp (LH)
(2TR–FE)
(∗4)
W–B
6 6
G
G
14 A (LHD)
Y
15 B (RHD)
W
T H EL
1
OFF
Engine ECU
< 4–10>
2 2
FR FOG Relay
< 10–1>
Tail
W
Light
Control SW
1 HH1
A21
Clearance Lamp
(Front LH)
A6
Clearance Lamp
(Front RH)
Head
(∗5)
W–B
1 1
GR
W–B
H28(A), H29(B) 16 A (LHD)

a4
License Plate Lamp
W
GR
W–B
Combination SW 9 B (RHD) 2
9 ZU1 1 3 2 3 TU2 (∗1) 4 TY2
BR
W–B
W–B
W–B
3 TU3 (∗2)
7 6F U2
2
W–B
W–B
Junction
(∗4)
Connector
W–B
9 Za1 5 TY2
a1
Junction
Connector
W
1
1 6F W–B
W–B
W–B
W–B
W–B
H2 A1 a1 a1 Y1 H2
365 HIACE (EM04Z2E)
Taillight System B–G
9 5S
1 5G
1 1G
< 13–1>
(BAT)
14 HIACE
120A
MAIN4
T–LP
Relay
1
3
5
4
W–B W–B G
1
H1
9 5Q
H14
10A
PANEL
2
6
5
W–B G
8 5Q
W–B
H16
A/C SW
H41
7
4
5
W–B G
9 5P
H17
Junction Connector
Rear Window
Defogger SW
1
2
11
W–B G
2 5Q
H13
Ashtray Illumination
9
2
1
13
W–B W–B W–B G

10 5P
(LHD) (LHD)
H10
Room Lamp SW
17 IH3 (LHD)
17 IH4 (RHD)
2
1
W–B G
(RHD) (RHD)
1
2
W–B G H9
(∗3) (∗3) Hazard Warning
Signal SW
I16
Power Slide Door Main SW
2
1
2
W–B G
(∗3) (∗3)
I15
Power Slide Door Control SW
6
3
W–B G
I9
1
3
W–B G G
10 A
9 B
3 B
4 A
I3
W–B Rear Fog Lamp SW G
12 A
2 A
(∗3) (∗3)
2
1
W–B W–B W–B G G
7 A
7 B
3 A
Illu m in a tio n
(LHD) (LHD) (∗3)

I12(A), I13(B) I4
Junction Hazard Warning
W–B
Connector Signal SW
I12(A), I13(B)
2
1
W–B G
Junction Connector
(RHD) (RHD)
I5
G
Room Lamp SW
W–B
2
1
W–B G
3
I6
G
Idle–Up SW
2
1
W–B G
I7
I2(A), I18(D) Door Lock
G
Radio Receiver Control SW
Assembly
W–B
BR BR G G G G
7 A
10 A
1 B
1 A
7 5Q
ILL+
GND
2 IH3 (LHD)
4 IH3 (LHD)
2 IH4 (RHD)
4 IH4 (RHD)
BR
BR G
6 B
4 D
17 D
TAIL
GND1
4
1
W–B W–B W–B G
1 6F
9 6F
10 6F
12 6F
8 5P
H2
H11
Rear Blower SW (Main)
1
2
W–B G
14 6F
6 5P
W–B(∗1)
H21
A/T Shift Lever Illumination
Clearance Warning G
7 5P
ECU< 26–4>
4
7
10
W–B W–B G
E1
6 5Q
1 HH1
(∗1) (∗1)
Pointer
ILL+
Illumination
W–B
(∗2)
Illumination
5
2
R R
8 5S
18 5E
B
(BAT)
H20
10A
Combination Meter
DOME
M
366
In te rio r L ig h t
1 2 3 4
(BAT)
∗ 1 : Super Long
∗ 2 : Except Super Long
∗ 3 : w/ Map Lamp 10A
∗ 4 : Except ∗3 DOME
∗ 7 : w/o Power Slide Door 2
2
R
R R
(∗5) (∗5)
R
R
R
(∗5 ∗6)
R
R
R
(∗5)
T1 18 5E
(LHD)
(RHD)
(∗5 ∗7)
5 Bq1 Junction Connector
5
3 3 1 L–B
5K A
5 MB1 1 IH2
3 4 2
R
8 5S
(∗5 ∗6)
B
H10
Room Lamp SW
I5
Room Lamp SW
R
R
(LHD)
(∗3)
(∗1 ∗3)
4 4
R(RHD)
R
R
R
(∗5)
(∗4)
(∗1)
L
L
R
R
(∗4)
(∗4)
(∗3)
1 A (∗8) 1 2 2
L
L
1 T2
1 B (∗9)
(LHD)
(RHD)
Junction
Connector 3
11 IH2 23 HB2 3
2
DOOR
OFF
ON
DOOR
OFF
ON
L–B
(∗1 ∗3)
L
R
(RHD)
T7
Room Lamp (Center)
T12
Room Lamp (Rear)
3 3
1 1
M3
Step Lamp (RH)
B33(A), q6(B)
Step Lamp (LH)
B
(∗4)
2 2 A (∗8)
DOOR
OFF
ON
L–B(∗1 ∗4 ∗9)
DOOR
2 B (∗9)
R
25 HB2
T4
Room Lamp (Front)
H20
Y
1 Combination
T5
Map Lamp
(∗1 ∗3 ∗8)
5 Meter
G
2 1
L–B
(∗5)
R–W
(∗1 ∗4 ∗8)
(∗1 ∗4 ∗8)
L
ON
OFF
DOOR
ON
OFF
DOOR
(∗3)
W–B
Door
HIACE (EM04Z2E)
1 MB1
R–B
R–B
T8
Room Lamp (Center)
T13
Room Lamp (Rear)
(∗5 ∗6)
(∗5 ∗7)
4 BT1 2 3
1 2 1 2
G
LG
Y
(∗4 ∗8)
LG(∗4 ∗9)
(∗1 ∗3 ∗8)
G (∗1 ∗3 ∗8)
(∗1 ∗3 ∗8) T3 1
GR
(∗5)
R–B
6 Bq1 Junction 1 SW2 SW
(∗2 ∗3)
W–B(∗3)
Connector
4 12
GR
W–B W–B
(∗2 ∗4 ∗8)
Y(∗1 ∗3 ∗9)
(∗3) (∗1 ∗3)
Y–R
GR(∗2 ∗4 ∗9) 2
T20
Diode
GR
GR(∗2 ∗3 ∗8) G R–G
W
B
(∗1 ∗4 ∗8)
(∗3)
(∗3)
(∗4)
W–B
Y(∗1 ∗4 ∗9)
(∗1 ∗3 ∗8)
(∗3)
G 2 1 Y–R
W–B
3 BT1 G(∗2 ∗9)
C
Y(∗4 ∗9)
7 5M 1 5K (∗1 ∗4 ∗8)
R–B
T19
(∗5 ∗6)
G T18 LG
Diode
12 (Door Courtesy (∗1 ∗9) Diode (∗3)
G(∗1 ∗3 ∗9)
GR(∗2 ∗3 ∗9)
R No. 9) (Door Courtesy
1 2 No. 7)
21 BT1
H41
Junction
Connector
1 12 5E 28 5A 22 BT1
2
1 3
(∗3)
W–B
(∗3)
R–L
W–B
T21
D
(∗3)
R–B
W–B
Diode
(∗5 ∗7)
R–B (Door Courtesy No. 11) R–B
E
R–B R–B R–B
F
(∗5) (∗5) (∗5)
H1 B3
15 HIACE (Cont' d)
In te rio r L ig h t
5 6 7 8
(BAT) (IG) Integration Relay
10A 7. 5A
ECU–B ECU–IG
SIG ECUB DCTY PCTY RCTY
2 5 6 26 20 22
W–R
17 5E 27 5E 10 5E 7 5D 12 5D 8 5D 9 5A 18 5A 30 5A
P
W–R L–B (∗11)
W (∗11)
R–L
R–B
R–G
(∗12)
G
W
W
(∗13)
1
A
R–L
R–L
(LHD)
(RHD)
R–G(LHD)
R–G(RHD)
1 3 1 3
4 5P
No. 6)
T17
Diode
(Door Courtesy
G
(∗12)
2 11 TU3 (∗14)
11 TU2 (∗15)
2 1
T9
Diode
T6
Diode
2 2
R
R
(∗16)
(∗10)
H35
R–L
R–G
2 Diode
B
P
(Door Courtesy
L–B
R–L
R–B
R–G
1 1
G
(∗11)
(∗11)
ILL+ No. 1)
1
13 6D 14 6D 5 6A 4 6A 4 6C 23 BT1 5 BT1
H24
Ignition Key
Cylinder Lamp
2
Ignition Key
Cylinder Lamp
4 TU3 (∗14)
B22
Door Courtesy SW
(Front LH)
B26
Door Courtesy SW
(Front RH)
L
L–B
ILL–
(∗11)
(∗11)
2 ZU1 4 TU2 (∗15) 4 TY1
H43
Transponder Key
Amplifier
6
16 6D 15 6D 18 6D 6 6A 7 6A 8 6A 6 6C 5 6C 7 6C
LG
R–Y
R–Y
(∗16)
(∗10)
B
R–L
R–L
R–L
R–G
R–G
R–G
(∗10)
R–B
R–B
2 Za1
R
1 3 3 UX1
HIACE (EM04Z2E)
R–B
R–B
H36
(∗5 ∗8)
(∗5 ∗9)
R–L
R–B
Diode
(Door Courtesy No. 2) Y–R 2
B
22 HB2 2
Door Control Relay (LH)
< 20–2>
2
Door Control Relay (RH)
< 20–4>
H37
Diode
1 1
LG
Power Window
Master SW
< 22–4> < 23–4>
R–G
1
R–L
H45
Diode
Transponder Key ECU

< 4–14> < 5–14>
R–B
1
X2
Door Courtesy SW
(Slide Door RH)
Y3
Door Courtesy SW
(Slide Door LH)
R–G
B
(∗5 ∗9)
Y–R
C
R–L
R–B
(∗17)
(∗17)
a2
Back Door
Courtesy SW
21 HB2 18 HB2
B
Option Connector 3
(TVSS ECU)< 34–2> ∗ 5 : w/ Step Lamp
(∗5)
R–B
R–B

a1
Junction
Connector
R–L ∗ 9 : From Oct. 2006 Production

D 1 ∗10 : w/ Engine Immobiliser System
R–B ∗11 : w/ Door Closer
W–B
E ∗12 : 6 Speaker
R–B ∗13 : Except ∗12
F ∗14 : Standard Body Standard Roof
(∗5) ∗15 : Except ∗14
a1 ∗16 : w/o Engine Immobiliser System
M
367
16 HIACE
368
ABS
1 2 3 4
(IG) (BAT) (BAT) (IG)
∗ 1 : Shielded
7. 5A 25A 40A 10A
ECU–IG ABS SOL ABS MTR MET IGN
2 2
7 5B 2 2 1 5M
DLC3< 29–4>
B–R
W
Stop Lamp SW
< 12–3>
W–R
A24
1 Short Pin (Vacuum)
IG1
W
L–Y
G–W
W
B–R
GND2 GND1 IG1 SIL

6 3 4 5
W
W
L–Y
B–R
6
W–B
W–B
G–W
IG+
22 AB1 15 AB1 18 HB4 14 AB1 7 AB1
ABS
W
W
L–Y
B–R
W–R
G–W
25 14 15 16 10 1 23
IG1 D/G TS TC STP +BS +BM
H20
Combination Meter
B19 LP
39
GND GND FL+ FL– FR+ FR– RL+ RL– RR+ RR– PKB WA
2 24 9 8 31 30 11 12 33 34 18 13
B–R
HIACE (EM04Z2E)
L
B
B
R
R
R
G
W
W
BR
BR
(∗1)
(∗1)
(∗1)
(∗1)
B–R
W–B
W–B
W–B
W–B
W–B
W–B
12 AB1 21 AB1 6 BP2 5 BP2 4 BP2 1 BP2 3 BP2 2 BP2 6 HB1
W–B
W–B
L
B
R
R
R
G
W
W
BR
BR
(∗1)
(∗1)
B–R
W–B
Combination Meter
< 28–6>
2 Pn1 1 Pn1 4 Pn1 3 Pn1

2 2
W–B
B
B
W
W
2 2
B20
Speed Sensor
(Front LH)
B18
Speed Sensor
(Front RH)
1 1
W–B
W–B
n1
Speed Sensor
(Rear LH)
n2
Speed Sensor
(Rear RH)
1 1
W–B
W–B
W–B
W–B
18 17 20
6
W–B W–B 16 19 W–B
AB1
A1 A2 B36
Junction Connector
17 HIACE
SRS C ig a re tte L ig h te r
1 2 3 4
(IG) (IG) (ACC)
15A 10A 15A

IGN MET IGN CIG
∗ 1 : w/ Front Passenger' s Airbag
1 5M 3 5Q
16 5E
B–R
Engine ECU
< 4–10>
6
IG+
B–Y
SRS
(2TR–FE)
R–W
14 5S 8 5E
B–O
DLC3
< 29–3> < 29–4>
SW
H20
Combination Meter
32 5E 40 15 5E
B–Y
L
W
P–B
B–Y
(2TR–FE)
21 A 14 A 22 A 15 A 16 A 1
H12
IG2 LA GSW2 TC SIL Cigarette
Lighter
B4(A), B5(B), B6(C)
Airbag Sensor Assembly Center 2
D+ D– P+ P– +SL –SL +SR –SR PD+ PD– PP+ PP– E1 E2

5 A 6 A 4 A 3 A 30 A 28 A 29 A 27 A 2 B 1 B 4 C 5 C 25 A 26 A
Y
BR
(∗1)
(∗1)
Y–B
Y–R
Y–G
B–W
W–B
W–B
W–R
BR–W
HIACE (EM04Z2E)
Y
Y
(∗1)
(∗1)
Y–B
Y–B
W–B
1 HB3 3 HB3 2 HB3 4 HB3 2 AB2 4 AB2 1 AB2 3 AB2
BR
(∗1)
(∗1)
Y–R
Y–G
B–W
W–B
W–B
W–R
BR–W
1 A 2 A (LHD) 1 A 2 A (LHD)
2 1 2 1 1 B 2 B (RHD) 1 B 2 B (RHD)
Y–B
2 HJ1 1 HJ1 +SL –SL +SR –SR L+(LHD) L–(LHD) R+(LHD) R–(LHD) 14 5E 30 5E
R+(RHD) R–(RHD) L+(RHD) L–(RHD) 4
W–B 12 H41
Junction
Connector
Pretensioner Pretensioner 1
1 2 A13 A12 12 5E 7 5M
Y
(∗1)
(∗1)
Y–B
D+ D– Airbag Sensor Airbag Sensor B23(A) B25(A)
(Front LH) (Front RH) Front Seat Outer Belt (LH) Front Seat Outer Belt (RH)
Spiral B25(B) B23(B) W–B
Cable Front Seat Outer Belt (RH) Front Seat Outer Belt (LH)
1 2
W–B
P+ P–
W–B
H32 J1
Airbag Squib Airbag Squib B3 H1
(Steering Wheel Pad) (Front Passenger' s
Airbag Assembly)
M
369
370
D o o r L o c k C o n tro l (L H D )
1 2 3 4
(BAT) (IG)
30A 7. 5A ∗ 2 : w/o Power Window
DOOR ECU–IG ∗ 3 : w/ Wireless Door Lock Control
H7(A)
ALTB SIG
L1 UL1 GND DBKL LSWD L2 UL2 ACT+ ACT–

12 10 1 21 A 20 A 14 16 2 3
A
(∗3)
W–B
24 5B 23 5B 6 5H 7 5H 7 5M 12 5E
W
(∗3 ∗4)
W
21 5B 22 5B 33 5B 34 5B 3 5B 4 5B
(∗3 ∗5)
(∗1)
(∗1)
(∗2)
(∗2)
L–Y
L–Y
L–W
L–W
W–B
W–B
L
R
L–Y
L–Y
L–W
L–W
7 HH1
1 LA1 4 LA1 9 IH3 18 IH3 R
W
(∗3 ∗4)
(∗1)
(∗1)
(∗2)
(∗2)
L–Y
L–Y
L–W
L–W
11 HA1
5 8 3 5
L UL L UL
L
L
R
R
LG
LG
LG
L–Y
L–Y
L–W
L–W
W
(∗3)
Lock
Lock
Unlock
Unlock
E E 2 LA3 3 LA3 7 LA3 7 LA2 6 LA2 2 LA2 3 KA3 7 KA3 7 KA2 6 KA2 2 KA2 25 HA1
L5
Power Window
Master SW
I7
Door Lock
Control SW
HIACE (EM04Z2E)
1 6
(∗2)
W–B
W–B
L
L
R
R
W
BR
BR
(∗3)
(∗2)
(∗2)
L–Y
L–Y
L–W
L–W
7 B
G(∗1)
G(∗1)
19 6F
(∗1)
W–B
I12(A), I13(B)
Junction
Connector
7 A 8 9 10 4 1 7 6 5 4 1 8
10 6F
(∗2)
W–B
M M
W–B
Key Lock
Key Lock
Key Unlock
Key Unlock
3 LA1 17 IH3 Unlock Detection
9 6F
(∗1)
(∗2)
W–B
W–B
L1 K1
7 13 Door Lock Assembly (Front LH) Door Lock Assembly (Front RH)
12 W–B
3 6F 1 6F
A25
Junction
Connector
H41
Junction
Connector
3 1
W–B
(∗1)
W–B
W–B
W–B
W–B
(∗3)
A1 H1 B3 H2
18 HIACE (Cont' d)
D o o r L o c k C o n tro l (L H D ) W ire le s s D o o r L o c k C o n tro l (L H D )
5 6 7 8
(BAT)
10A
ECU–B
H7(A) 2
Integration Relay
W–R
DCTY PCTY RCTY KSW HAZ PRG RDA ECUB

26 20 22 9 25 6 A 7 A 6
A
17 5E
B
W
B
W–R
9 HB1 8 HB1 W–R
Flasher Relay
< 11–1>
26 5E 11 5E 25 5A 29 5A
Unlock Warning SW
< 25–1>
L
L
B
R
R
W
W–R

< 15–5> < 15–6> < 15–7>
R
L 13 BT1 7 BT1 6 BT1

1 TU1 6 TU1
L
L
R
R
O
GR
L
R
2 NB1 5 NB1 4 MB1 3 MB1
1 TY1 10 TY1 2 TY1
L
L
R
R
HIACE (EM04Z2E)
1 ZU1 5 ZU1
2 3 2 3
L
R
O
GR
G
G
L–B
L–B
1 Za1 5 Za1
3 2 5
G
G
PRG RDA +B
L–B
L–B
L
1 2 1 2 P
GND
Y2 1
2 1 Door Control Receiver
M M

(Slide Door LH) (Slide Door RH) M
N1
Slide Door Control
Junction (Male LH)
M1
Slide Door Control
Junction (Male RH)
W–B
a3
Back Door
Lock Assembly
Y1
M
371
372
D o o r L o c k C o n tro l (R H D )
1 2 3 4
(BAT) (IG)
∗ 1 : w/ Power Window ∗ 6 : w/ Option Connector (TVSS)

30A 7. 5A ∗ 2 : w/o Power Window ∗ 9 : Before Apr. 2009 Production
DOOR ECU–IG ∗ 3 : w/ Wireless Door Lock Control ∗10 : From Apr. 2009 Production
∗ 4 : 5L–E, 2TR–FE ∗3, 1KD–FTV ∗3, 2KD–FTV ∗3
∗ 5 : 2TR–FE w/o Wireless Door lock Control, 1KD–FTV W/o wireless Door Lock Control
2KD–FTV w/o Wireless Door Lock Control
H7(A)
ALTB SIG
L1 UL1 GND DBKL LSWD L2 UL2 ACT+ ACT–

12 10 1 21 A 20 A 14 16 2 3
A
LG
(∗3)
B
6 5B 5 5B 6 5H 7 5H 7 5M 12 5E
W
(∗3 ∗9)
(∗2)
(∗2)
L–Y
L–W
3 5B 4 5B 33 5B 34 5B 21 5B 22 5B
(∗1)
(∗1)
L–Y
L–W
W–B
W–B
7 HH1
(∗6)
(∗2)
(∗2)
(∗6)
L–Y
L–Y
L–W
L–W
(∗3 ∗10)
L
R
L–Y
L–Y
L–W
R L–W
1 KA1 4 KA1 9 IH4 18 IH4

(Driver' s Side)< 25–2>
W
L
(∗3 ∗9)
(∗1)
(∗1)
(∗2)
(∗2)
L–Y
L–Y
L–W
L–W
Option
Connector
(TVSS ECU)
< 34–2>
Option
Connector
(TVSS ECU)
< 34–2>
11 HA1
5 8 3 5
L UL L UL
L
L
R
R
LG
LG
LG
L–Y
L–Y
L–W
L–W
W
(∗3)
Lock
Lock
Unlock
Unlock
E E 2 KA3 3 KA3 7 KA3 7 KA2 6 KA2 2 KA2 3 LA3 7 LA3 7 LA2 6 LA2 2 LA2 25 HA1
K5
Power Window
Master SW
I7
Door Lock
Control SW
HIACE (EM04Z2E)
1 6
(∗2)
W–B
(∗4)
W–B
L
L
R
R
W
BR
BR
(∗3)
(∗2)
(∗2)
L–Y
L–Y
L–W
L–W
7 B
G(∗1)
G(∗1)
LG
(∗5)
19 6F
(∗1)
W–B
I12(A), I13(B)
Junction
Connector
7 A 7 6 5 4 1 8 9 10 4 1 7
10 6F
(∗2)
W–B
M M
(∗4)
W–B
Key Lock
Key Lock
Key Unlock
Key Unlock
3 KA1 17 IH4
Unlock Detection
(Driver' s Side)< 25–2>
9 6F
(∗1)
(∗2)
W–B
W–B
K1 L1
13 Door Lock Assembly (Front RH) Door Lock Assembly (Front LH)
12 W–B
1 6F
H41
Junction
Connector
1
(∗1)
(∗4)
W–B
W–B
W–B
W–B
A1 H1 B3 H2
19 HIACE (Cont' d)
D o o r L o c k C o n tro l (R H D ) W ire le s s D o o r L o c k C o n tro l (R H D )
5 6 7 8
(BAT)

∗ 8 : w/o Power Slide Door 10A
ECU–B
H7(A) 2
Integration Relay
W–R
LSD1 DCTY PCTY RCTY KSW HAZ PRG RDA ECUB

5 A 26 20 22 9 25 6 A 7 A 6
A
(∗7)
B–L
17 5E
B
W
Flasher Relay 9 HB1 8 HB1 W–R

< 11–1>
26 5E 11 5E 25 5A 29 5A
Unlock Warning SW
< 25–1>
L
L
B
R
R
W
W–R

< 15–5> < 15–6> < 15–7>
R
Door Control Relay

(Power Slide Door)< 33–6>
(∗8)
L 13 BT1 7 BT1 6 BT1
(∗8) 1 TU1 6 TU1
R
(∗7)
(∗7)
7 Bq1 2 Bq1
O
GR
L
L
L
R
R
R
(∗8)
(∗8)
(∗8)
(∗8)
R
(∗7)
(∗7)
1 TY1 10 TY1 2 TY1
4 oq1 5 oq1 2 NB1 5 NB1 4 MB1 3 MB1
HIACE (EM04Z2E)
1 ZU1 5 ZU1
R
(∗7)
(∗7)
L
L
L
R
R
R
O
GR
(∗8)
(∗8)
(∗8)
(∗8)
18 po1 9 po1
2 3 2 3 1 Za1 5 Za1
R
(∗7)
(∗7)
3 2 5
G
G
L–B
L–B
PRG RDA +B
3 2
UL L
L
P
GND
G
G
L–B
L–B
M Y2 1
1 2 1 2 Door Control Receiver
2 1
M M
p5
W–B
Slide Door Lock

Remote Control Assembly Door Lock Motor Assembly Door Lock Motor Assembly M
N1
Slide Door Control
Junction (Male LH)
M1
Slide Door Control
Junction (Male RH)
a3
Back Door
Lock Assembly
Y1
M
373
20 HIACE
374
D o o r C lo s e r
1 2 3 4
(BAT)
30A
RR DOOR
B–R
7
B–R B–R
MB1
B–R
B–R
B32 M2
1 Door Control Relay (LH) 1 Door Control Relay (RH)
B B
E SW RLY PCTY E SW RLY PCTY

3 4 5 2 3 4 5 2
W–B
W–B
L
Y
L–B
W–B
W–B
6 NB1 1 NB1
W–B W–B
6 MB1
W–B
5 1 4 5 1 4
N1 M1
L
Slide Door Control L Slide Door Control
R
R
W
W
Junction (Male LH) Junction (Male RH)
L
L–B
L
L
R
R
W
W
HIACE (EM04Z2E)
L
L
1 2 1 2
B
B
R
R
7 5 Slide Door Closer Relay 7 5 Slide Door Closer Relay

GND +B GND +B
Door Courtesy SW
(Slide Door LH)< 15–8>
Door Courtesy SW
(Slide Door RH)< 15–8>
DC+ DC– POS SWE PAWL HALF FULL DC+ DC– POS SWE PAWL HALF FULL
2 1 10 8 9 3 4 2 1 10 8 9 3 4
L
L
Y
B
Y
B
R
R
G
G
B
B
R
R
W–B
W–B
W–B
2 1 2 1
M Handle SW M Handle SW
4 NB1
Initial
Position SW
Initial
Position SW
8 MB1 2 MB1
Pawl
Position SW
Pawl
Position SW
Slide Door Slide Door
W
W
Closer Motor Closer Motor

L L L L
W–B
L
L
W–B
W–B
W–B W–B
Latch SW
Latch SW
W–B
W–B
B3 B2
21 HIACE
R e m o te C o n tro l M irro r S h ift L o c k
1 2 3 4
(ACC) (IG)
7. 5A 7. 5A
ACC ECU–IG
GR
6 5S 4 5S 7 5S
I8
Outer Mirror SW 8
B
GR
GR
B–R
Left/ Right/ 13 IH3 (LHD)
Left Right Up Down
Up Down 13 IH4 (RHD)
Operation SW
5 6B
GR
MH MV
Retract SW
Stop Lamp SW
< 12–3>
Left Right Left Right 1

I14
Junction 7 6B
Select SW
Connector
MH MV MLH MRH MLV MRV M+ E
4
10 9 5 2 4 3 6 7
GR
B–R
G–W
GR
B
G
W
R–Y
R–W
LG–B
(RHD)
(RHD)
H22
6 1 Shift Lock Control ECU 7
W–B
14 IH4 5 IH4 2 IH1 10 IH1 1 IH1 9 IH1 17 IH1 (LHD)
7 IH4 6 IH4 16 IH4 15 IH4 8 IH4 (RHD) ACC IG STP
R–Y
G
8 B
B
R–W
(RHD)
(RHD)
W 30 HA1 KLS+ E P E SLS– SLS+
29 HA1 5 HA1 12 8
I12(A), I13(B)
Junction
Connector
G G 7 A
R–Y
LG–B
B
L–W
W–B
32 HA1 9 HA1 33 HA1 18 HA1
(RHD)
(RHD)
HIACE (EM04Z2E)
W–B
4
G
G
R–Y
P
R–W
LG–B
17 IH3 (LHD)
H26
17 IH4 (RHD) Unlock
4 LA2 3 LA2 8 LA2 4 KA2 3 KA2 8 KA2 Warning SW
Shift Lock Solenoid
Key
Interlock
Solenoid
Y
Y
R
G
W
3
R–W
2 3 1 2 3 1
W–B
W–B
MH MV M+ MH MV M+
W–B
W–B
13 13 6F 10 6F 9 6F
MR MF MR MF
H41
Junction
Connector
5 4 L3 5 4 K3 1
Outer Rear Outer Rear
View Mirror (LH) View Mirror (RH) 15 6F 1 6F
L
L
B
B
(RHD)
(RHD)
(RHD)
(RHD)
W–B
1 LA2 5 LA2 1 KA2 5 KA2

W–B
W–B
L
L
B
B
(RHD)
(RHD)
(RHD)
(RHD)
L L(RHD)
(RHD) H1 H2
B B
(RHD) (RHD)
M
375
22 HIACE
376
P o w e r W in d o w (L H D )
1 2 3 4
(IG) (BAT) (BAT)
10A 120A 30A L5

GAUGE MAIN4 DOOR
1 1G 1 5H
BW B UH DH VCC PLS2 PLS GND U D E CTY

7 6 13 15 3 17 14 2 4 9 1 11
B–G
L
L
R
R–L
W–R
L
Y
Y
R
W
BR
W–B
1 5G
7 HA2 5 LA3 1 LA3 5 LA1 2 LA1 3 LA1 6 LA3
4 3 5 6 2 1
R–L
W–R
VCC PLS2 PLS E U D
L
R–L
W–L
W–B
PWR
Relay
W–L 22 HA1
L
M
R–L
W–L
R–L
1 KA3 5 KA1 2 KA1

30A
PWR
L4
2 Power Window Regulator Motor (Front LH)
L
L
R–L
12 5E 7 5M 36 5B
4 5 2
W–L
B SU SD
HIACE (EM04Z2E)
W–B
W–B
Door Courtesy SW (Front RH)
< 15–7>
Diode (Door Courtesy No. 1)

< 15–7>
Up
Down
U D
K6
Power Window SW
(Front RH)
3 1
Y
G
W–B
12
2 1
7
U D
H41
Junction
Connector
1
A25
Junction
Connector
3
M
W–B
K4
W–B
Power Window
Regulator Motor
14 (Front RH)
HA2
W–B
B3 H1 A2 A1
23 HIACE
P o w e r W in d o w (R H D )
1 2 3 4
(IG) (BAT) (BAT)
10A 120A 30A K5

GAUGE MAIN4 DOOR
1 1G 1 5H
BW B UH DH VCC PLS2 PLS GND U D E CTY

7 6 13 15 3 17 14 2 4 9 1 11
B–G
L
L
R
R–L
W–R
L
Y
Y
R
W
BR
W–B
1 5G
7 HA2 5 KA3 1 KA3 5 KA1 2 KA1 3 KA1 6 KA3
4 3 5 6 2 1
W–R
VCC PLS2 PLS E U D
L
R–L
R–L
W–L
W–B
PWR
Relay
W–L
22 HA1
L
M
R–L
W–L
1
R–L
1 LA3 5 LA1 2 LA1

30A
PWR
K4
2 Power Window Regulator Motor (Front RH)
L
L
R–L
12 5E 7 5M 36 5B 4 5 2
B SU SD
W–L
HIACE (EM04Z2E)
W–B
W–B
Up
Down
Door Courtesy SW (Front LH)
< 15–7>
< 15–7>
U D
L6
Power Window SW
(Front LH)
3 1
Y
G
12 2 1
U D
H41
Junction
Connector
1
L4
W–B
Power Window
Regulator Motor
W–B
(Front LH)
14
HA2
W–B
B3 H1 A2 A1
M
377
24 HIACE
378
F ro n t W ip e r a n d W a s h e r R e a r W ip e r a n d W a s h e r
1 2 3 4
(IG) H30(A), (B) (IG) (IG)
Combination SW
25A 20A 15A

Front Wiper SW Front Washer SW RR H30(A), (B)
WIP WSH
WIP–WSH Combination SW
+2 +1 +B +S INT1 INT2 B1 WF E
WR +1R C1R E
MIST Off
Washer
OFF On
2 5H 12 5B 10 5A 9 5H
OFF
INT
LO
R–L
L
LO
Rear Wiper and

Washer SW
L–R
HI
HI
2 HA2
1 On+Washer
17 6E
A17
Windshield 12 A 10 A 13 A 2 A (LHD)
M
B–R
Washer Motor 16 B 18 B 15 B 8 B (RHD)
(∗1)
(∗1)
R–L
2
1
18 6E 19 6E
A18
L–R
B–R
R–B
W–B
Wiper Relay Rear Washer
B
M
Motor
8 HB2 15 HB2
L
L
2
+B +2 +1 +S E WF
B–R
17 A 8 A 7 A 16 A 2 A 11 A (LHD) 10 HA2 7 dT1
L–R
R–B
11 B 2 B 3 B 12 B 8 B 17 B (RHD)
L 5 HA2
B
15 BT1 9 BT1
W–B
B–R
P
LG
L–R
B–R
20 6E 5 dT1 6 dT1
R–B
P
LG
22 6E d2
HIACE (EM04Z2E)
1 Rear Wiper Motor 3 2
4 6F B S +1
L–R
6 HA2 11 HA2 9 HA2 4 HA2

W–B
1 6F
L–R
R–B
∗ 1 : w/ INT Time SW
W–B
4 A 1 A 3 A 2 A (LHD) 4 6F
3 B 5 B 1 B 2 B (RHD)
+2 +1 +S B
M
1 6F
Rear Wiper
Relay
E Rear Wiper
M
W–B
A11(A), (B) 5 A (LHD) Motor

Windshield Wiper Motor 4 B (RHD)
W–B
W–B
A1 H2 H2
25 HIACE
K e y R e m in d e r a n d L ig h t R e m in d e r S e a t B e lt W a rn in g H e a d lig h t B e a m L e v e l C o n tro l
1 2 3 4
(BAT) (IG) (IG) (BAT)
W–L
10A 10A 10A 40A

DOME MET IGN GAUGE HEAD
4
2 2
1
2 1 5M 1 5P 2
∗ 3 : Before Oct. 2006 Production, RHD From Oct. 2006 Production 15A
until Apr. 2009 Production HEAD LH
R
W–R
∗ 5 : RHD Before Sep. 2007 Production
L–R
B–R
(RHD)
∗ 6 : RHD From Sep. 2007 Production 2
18 5E
∗ 7 : RHD From Sep. 2007 Production 7 L
W–R
W–R
BD 4
∗ 8 : RHD From Apr. 2009 Production
Front Passenger' s 4 4
Seat Belt
8 5S Warning Light
L
DOSW 1 3 6 HA1
H15
Clearance Warning
Indicator
8
R
B–R
H20
5 Combination Meter 6 8 AB1
L
L
HEAD Relay
B IG+
2 5
L
Buzzer
W
(∗5)
L 18 IH1
Driver' s
Seat Belt
4 4 L
L
L
W–L
W
(∗6)
(∗8)
(∗7)
R–B
B–R
KSW SW ILL+ E1 L
7 HB1 3 3 2
11 12 10 7 19
LH T RH T B
Transponder Key ECU

< 4–14> < 5–13>
Integration Relay
< 18–7> < 19–7>
Y
W
LG
(RHD)
9 5D
2 HB2
2 RB1
(∗3)
W–B
Headlight System
< 9–4>
LG
Y
(∗1)
HIACE (EM04Z2E)
LH E LHIG RH E RHIG RH+ LH+ E
Combination Meter
< 28–3>
14 5H (RHD)
A20
Headlamp Leveling
Motor (LH)
A8
Headlamp Leveling
Motor (RH)
I9
W
(RHD)
1 2 1 2 5 4 1
LG
Y
(LHD)
LG
Illumination System
< 14–4>
(∗4)
W–B

< 15–4>
(RHD)
(∗1)
Y
(∗2)
L–B
R–Y
2
W–B
L–B
R–Y
W–B
W–B
4 6B 1 6B 11 6C 2 RB1
LG
1 HH1 7 HB2 2 IH2 13 IH2 12 IH2
(RHD)
W
8
(LHD)
2 2
LG
Occupant
Detection
Sensor
L–B
R–Y
W–B
2 6B 3 6B 12 6C 13 6C
(RHD)
A25
Junction
Connector
Y
Y
Y–B
Y–B
1 R1 16 HA1 31 HA1 7 HA1
B11
(Driver' s Side)
R2
(Driver' s Side)
(A/T ∗1)
(A/T ∗2)
(M/T ∗1)
(M/T ∗2)
1 1 Front Seat Inner Belt
W–B
W–B
W–B
(LHD)
2 2 (RHD)
L–B
W–B
9 6F
1 RB1
(∗3)
W–B
W–B
(RHD)
H26
Unlock
Warning SW
H27
Unlock
Warning SW
Integration Relay
(w/ Wireless Door lock)
< 19–2>
Door Lock Assembly
(Front LH), (Front RH)
(w/o Wireless Door Lock)
< 19–4>
W–B W–B
1 1
W–B
1 6F W–B W–B
W–B
W–B
(A/T)
(M/T)
(LHD) (RHD)
W–B
16 6F 17 6F 10 6F
W–B
W–B
H2 H2 B2 B3 A1
M
379
26 HIACE
380
P a rk in g A s s is t (T O Y O T A P a rk in g A s s is t– S e n s o r)
1 2 3 4
(IG)
10A
W–B
GAUGE
H15
Clearance Warning Indicator 1
E
1 5P
BD SK BZ OP BK FL RL FR RR
7 12 11 10 9 5 4 3 2
Combination
Meter< 28–2>
Park/Neutral
Position SW (A/T)
< 12–1>
Back–Up Light SW (M/T)
< 12–1>
Park/Neutral
Position SW (A/T)
< 7–7>
PANEL Fuse
< 14–4>
L–R
L–R
L
Y
L–B
L–R
Y–B
Y–R
Y–G
L–W
L
G
P–L
(A/T)
R–W
8 10 30 11 31 12 32 13 25 9 28 26
IG CBZ L10 L7 L4 L6 L1 L5 SPD RL PL TL
H33
E S1 E1 S4 E4 S5 E5 S6 E6 S7 E7 S8 E8
27 1 14 2 15 3 16 4 17 5 18 6 19
B
B
Y
P
V
Y
R
R
G
W
W
24 HA1 39 HA1 23 HA1 38 HA1 2 HB4 13 HB4 5 HB4 16 HB4 4 HB4 15 HB4 3 HB4 14 HB4
L
B
Y
P
V
Y
W–B
4 BP3 9 BP3 1 BP3 6 BP3 3 BP3 8 BP3 2 BP3 7 BP3
R
G
W
L
B
Y
P
V
Y
R
W
HIACE (EM04Z2E)
1 CA1 4 CA1 3 CA1 6 CA1 1 SP1 5 SP1 4 SP1 8 SP1 2 SP1 6 SP1 3 SP1 7 SP1
20 6F
L
B
B
Y
P
V
Y
R
R
G
W
W
10 6F
W–B
1 WS1 5 WS1 4 WS1 8 WS1 2 WS1 6 WS1 3 WS1 7 WS1
W–B
L
B
P
V
Y
R
W
GR
9 6F 2 2 2 2 2 2 5
S S S S S S
H41
Junction
Connector
1
E E E E E E
C3
(Front RH)
C1
(Front LH)
W4
(Rear RH)
W1
(Rear LH)
W3
(RH)
W2
(LH)
1 6F 1 1 1 1 1 1
W–B
W–B
W–B W–B
H2 H1
27 HIACE
R e a r W in d o w D e fo g g e r A u d io S y s te m
1 2 3 4
L2 K2
(BAT) (IG) (BAT) (ACC) Speaker Speaker
(Front Door LH) (Front Door RH)
1 2 1 2
30A 10A 15A 7. 5A
DEF GAUGE RADIO ACC
R
W
2 2
4 LA3 8 LA3 4 KA3 8 KA3

2 6 5S
L
P
V
LG
GR
L–Y
DEF 13 IH3 (LHD) 8 HA2 13 HA2 12 HA2 15 HA2
10A Relay 13 IH4 (RHD)
ELS I14
Junction
L
P
V
3 HB1 Connector
LG
GR
1 2
L–Y
3 13 IH1 14 IH1 15 IH1 5 IH1
11 5M 2 5F 12 5Q 4 5Q
L
B
B
P
V
W
W
LG
GR
GR
(∗5)
(∗5)
(∗5)
(∗5)
(∗5)
6 IH1
18 D 3 A 10 C 9 C 11 D 3 D 2 A 6 A 1 A 5 A
ACC ACC TX+ TX– TX– TX+ FL+ FL– FR+ FR–
B
I1(B), I2(A), I17(C), I18(D)
L–Y
L–R
L–R
P–B
(2TR–FE)
1 B +B TX3– GND GND1 RL+ RL– RR+ RR–
5 HB2 3 4 A 8 D 10 D 7 A 4 D 2 B 6 B 1 B 3 B
I11
Junction
Connector
2
B
Y
R
W
BR
BR
(∗5)
(∗5)
(∗5)
L–Y
L–Y
W–B
B
(∗5)
L–Y
L–Y
4 IH1 12 IH1 3 IH1 11 IH1
Engine ECU
< 4–10>
7 BT2
L–R
P–B
1 A
B
Y
R
W
2 3 43 HB1 5 HB1 42 HB1 4 HB1
HIACE (EM04Z2E)
D IG
b1(A), b2(B)
Rear Window
Defogger
1 B
B
Y
R
W
BR
B
12 B 2 IH3 (LHD) 5 BT2 6 BT2 9 BT2 10 BT2
Timer
8 dT1 2 IH4 (RHD)
H17
Rear Window
Defogger SW
1 db2 E Y W
I12(A), I13(B)
Junction
Connector
1 7 A (∗2) (∗2)
Off
BR
L
B
Y
R
W
(∗1)
(∗1)
B
On
(∗5)
W–B
∗ 1 : 4 Speaker 2
W–B
∗ 2 : 6 Speaker 2
L

(∗2)
1 db1 1 dT1 17 IH4 6 TY1 5 TY1 9 TU3 (∗3) 8 TU3 (∗3)

P
∗ 4 : Except ∗3
(∗2)
T11
Speaker
(Roof RH)
6 9 TU2 (∗4) 8 TU2 (∗4)

H41 ∗ 5 : w/ Radio Data System 1
T10
Speaker
(Roof LH)
Junction 1
Connector
(∗5)
B
B
Y
R
W–B
W
W–B
1
13
1 UX1 2 UX1
3 TY1
H41
Junction
Connector
1
R
W
W–B
1 2 1 2
BR
(∗5)
W–B
W–B
Y1 X1
Y1 H1 H1 H2 Speaker Speaker
(Rear LH) (Rear RH)
M
381
HIACE (EM04Z2E) 382
L–R L–R L–R
2 5E
(IG)
5 DB4
10A
28 HIACE
GAUGE
Door
4
5
2
R R
2
8 5S
18 5E
B
(BAT)
SW2

< 15–4>
1
10A
12
DOME
SW
Pointer
Illumination
Option Connector P
(TVSS ECU)
< 34–2> (∗12)
Illumination
1
3
15
L–R P P P P
SI
IG+
3 DB4
58 HB1
SI
∗ 3 : 5L–E
∗ 1 : 2TR–FE
D38
∗14 : w/o ABS
2
29
BR BR BR Speedometer
Speed
Sensor
E
E3
7 DB4
22 HB1
h1(A)
Fuel Sender Gage
h2(B)
Tachometer

Gage Assembly
13
Y–R Y–R Y–R Y–R

2 Ph1
3 BP1
20 HB1
L
3 B (∗1)
2 B (∗1)
Gage Fuel
3 A (∗2, ∗3)
2 A (∗2, ∗3)
8

E2
4 Ph1
7 BP1
44 HB1
2
Temp.
B35
∗16 : w/ Front Passenger' s Seat Belt Warning From Apr. 2009 Production
∗15 : w/ Front Passenger' s Seat Belt Warning From Sep. 2007 Production
Junction
Connector
7
4
9
Engine ECU P–L P–L P–L

24 5E
14 5D
< 4–10> < 5–8> < 6–7>

+S
5
Door Control Relay P–L
(Power Slide Door)
(∗6)
H20
< 33–6>
Clock /
ODO LCD
6
Transmission P–L
Control ECU
< 8–4> (∗5)
H42
Combination Meter
Junction
Connector
11
Clearance Warning P–L P–L
13 5H
Buzzer
ECU< 26–3>
9
A/C Amplifier P–L
< 30–7>
R–B
(∗16)
12
15
W–B W–B W–B Clearance Warning
B2
(∗2, ∗3) (∗2, ∗3) Indicator< 25–3>
28
B–R
C o m b in a tio n M e te r a n d C lo c k
B36
Junction (∗15)
Connector
PBLT
W–B
W Front Seat Inner Belt
B21 (∗15) < 25–3>
3
Fuel Sedimentary
W–B
(∗2, ∗3)
Level Warning SW
2
1
16
R–B R–B
34
37 HB1
L
(∗2, ∗3) (∗2, ∗3) R R Park/Neutral
Position SW
34 HB1
(∗4) (∗4) < 2–2>

ST(4)
11
Key Reminder and
Light Reminder
P/SB(∗15)
8
System< 25–1>
DB4
KSW
19
Seat Belt Warning
L
System< 25–2>
W–B
20
Y–G Y–G Y–G
4 DB4
19 HB1
OIL
2 A (∗1)
1 A (∗1)
2 B (∗2, ∗3)
1 B (∗2, ∗3)
17
Y
Engine Oil
S
Oil Level
Level Sensor
6
Engine ECU B–R
D11(A), D12(B)
< 4–11> < 4–12> < 5–8>
1 5M
(IG)
< 6–6> < 6–7>
IG+
14
B–Y
S
T–Belt
10A
B30
Fuel Filter
MET IGN
Warning SW
2
1
18
W–B W–B LG LG
Filter
B3
6 HB2
S
(∗2, ∗3) (∗2, ∗3) (∗2, ∗3)
4
Clock SW
Fuel
ODO TRIP SW Driver' s
Seat Belt
Taillight System Tail
10
< 13–4>
Illumination System
W–B
(∗14)
< 14–4>
ILL+
A
(Cont. next page)
383 HIACE (EM04Z2E)
A
W–B
(∗14)
Glow
25

L
< 5–7> < 6–3>

Check Engine
32

< 4–6> < 5–7> < 6–3>
EGW
∗
∗
∗
∗
SRS
28 HIACE (Cont' d)
40
7
3
2
1
SRS System
5
< 17–2>
SW
: 5L–E
∗13 : w/ ABS
: 2TR–FE
ABS
∗14 : w/o ABS
39
W–B B–R
∗10 : Except ∗11
6 HB1
(∗14) (∗14)
LP
: 1KD–FTV, 2KD–FTV
ABS System
< 16–4>
(∗13)
Oil Pressure
27
W W W
2 DB4
35 HB1
S
1 B (∗3)
1 A (∗1, ∗2)
Engine Oil
: Before Oct. 2006 Production, RHD From Oct. 2006 Production
Charge
D7(A), D8(B)
Pressure SW
33
Charging System
< 2–4>
CHG–
B
(∗13 ∗10)
H48
Junction
6
Connector
Brake
4
1
37
Skid Control ECU B B B

with Actuator
38 HB1
< 16–4> (∗13) (∗11 ∗13) (∗11 ∗13)

PKBI
B
(∗11 ∗13) Security
35
R Transponder Key ECU

3
B (∗9) < 4–14> < 5–13>

LP
(∗11 ∗13)
H20
Combination Meter
36
2 5D
(∗13 ∗10)
B B SW P
2 5C
24
56 HB1
(∗13 ∗10)
P
C o m b in a tio n M e te r a n d C lo c k
B(∗1)
R
17 5B
23
B
R
(∗2, ∗3)
7
1
22
1
5
B
N
A25
(∗2, ∗3)
Junction
2
Connector
A9 D
21
Brake Vacuum ECT and A/T Indicator System

Warning SW < 7–7> < 7–8> < 8–7> < 8–8>
D
2
1
W–B B
E
3
A1
1
(∗2, ∗3)
3
A10 B
Brake Fluid (∗1)
Level Warning SW
2
2
2
1
13
12
B B
L
3
B3 B34
L
Parking Brake SW Junction
Connector
High Beam
38
Headlight System
+
< 9–3>
Turn LH
31
B
Turn Signal and
Hazard Warning Light
Turn RH System< 11–2>
26
8
B
Front Fog
7
30
W–B W–B Front Fog Light System
H2
1 HH1
(∗7) (∗7) < 10–1>
E1
FOG
W–B
(∗8)
M
29 HIACE
384
C o o lin g F a n DLC3
1 2 3 4
(IG) (BAT) (BAT) (BAT) (BAT)
10A 50A 50A 30A 7. 5A

GAUGE FAN1 FAN2 FAN3 OBD
Engine ECU
< 4–12> < 5–8> < 6–7>
Airbag Sensor
Assembly Center
< 17–2>
Skid Control ECU
with Actuator
< 16–2>
Transponder Key ECU
< 4–14> < 5–13>
9 5C 4 1C 4 1B 3 1C 5 5S
∗ 1 : 2TR–FE
B
∗ 3 : 5L–E
L–R
B–R
R–B
(∗2, ∗3)
P
P
B
W
W
W
W

(∗4)
L–Y
P–B
59 HB1
(∗2, ∗3)
∗ 6 : 2KD–FTV
7 5E 3 5E 13 5E 31 5E 26 5B 25 5B
L–R
7
10 L–R
(∗2, ∗3)
4 5H 3 5S
9 L–R W
W (∗4)
B36
Junction Connector
8 (∗4)
L–R
B–R
L–R
R–B
(∗2, ∗3)
(∗2, ∗3)
L–R
1 1 18 6C 19 6C
W
(∗5)
B
L–Y
P–B
1 1 2 1I 1 1I
1 3
1 3 FAN2 17 6C
Relay
Engine ECU
< 5–8>
Engine ECU
< 5–8>
Engine ECU
< 4–11> < 6–5>
FAN1 FAN3 W
Relay 2 5 Relay (∗4)
13 7 12 16
2 5 TC SIL TS BAT
1 1 H23
(∗2)
P–L
DLC3
LG–B
(∗1, ∗3)
1 1 3 1I 4 1I WFSE TAC CANH CANL SG CG
(∗2)
4
W–B
LG–B
15 9 6 14 5 4
HIACE (EM04Z2E)
LG–B LG–B 5
R
W–L
W–B
BR
(∗6)
L–R
B–Y
(∗1, ∗3) (∗1, ∗3)
B36
Junction
Connector
(∗2, ∗3)
6 (∗2, ∗3)
LG–B
B–W
W–B
(∗1, ∗3) 5 AB1 12 HB4

R
W–L
1 A 2 A 1 A 2 A
(∗2, ∗3)
(∗2, ∗3)
BR
+B1 SI +B2 SI2

2 6F
2
M+ M– E1 M+ M– E2 2 DB5 (∗1)
B27(A), m1(B)
Cooling Fan
ECU No. 1
B28(A), m2(B)
Cooling Fan
ECU No. 2
M
2 B 1 B 3 A 2 B 1 B 3 A 9 DB2 (∗2)
A22
Cooling Fan Motor No. 2
9 DB1 (∗3)
Engine ECU
< 4–12> < 5–8> < 6–7>
R
R
W
W
1
1 6F
W–B
Engine ECU
< 5–8> < 6–5>
BR
M M
(CAN)< 30–11>
10
W–B
(∗2, ∗3)
D43
m1(B) m2(B) Junction
4
W–B
Cooling Fan Motor No. 1 Cooling Fan Motor No. 1 Connector
W–B
W–B
1
A25
Junction
Connector
W–B
3
W–B W–B W–B

W–B
BR
BR
(∗1)
(∗2)
(∗3)
W–B
W–B
W–B
(∗2, ∗3)
B2 B1 B3 A1 D2 D3 D4 H2
Memo
HIACE (EM04Z2E) 385

386
F ro n t A ir C o n d itio n e r (2 T R – F E , 1 K D – F T V , 2 K D – F T V ) a n d P T C H e a te r (2 K D – F T V )
1 2 3 4
(BAT) (IG) (BAT) (BAT)
40A 10A 50A 50A H18

HTR GAUGE PTC1 PTC2 A/C Amplifier
PTCL PTC PHTR
∗ 1 : Wide Body 3 2 5
LG
GR
L–W
2 1B 1 1F 1 1H
54 HB1 16 HB1 6 IH2
B–R
GR
W
L–W
1 5L LG
GR
L–W
1 A (LHD)
4 B (RHD) 1 1 1 1
5 2
HI
4 HTR 5 1 5 1
Relay
PTC1 PTC2 3
H1(A), (B)
3 1 Relay Relay
Blower Resistor
(Front A/C)
3 2 3 2
I6
Idle–Up SW
12 5E 7 5M 7 5F 5 5Q 4 5Q 4
1 1 1 1
L
L
L
M2 M1 E L–B
W–B
W–B
R–B
L
W–B
W–B
3 A 2 A 4 A (LHD)
L–R
W–B
2 B 3 B 1 B (RHD)
2
L–B
L–B
R–B
M
3 eB1 1 eB1 2 eB1 (∗1)
H2
Blower Motor
(Front A/C)
R
1
L–B
L–W
W–B
3 eB2 1 eB2 2 eB2 (∗2) 7 B
B
L–B
R–B
L–W
L–W L–W
I12(A), I13(B)
Junction
Connector
HIACE (EM04Z2E)
1 A 3 A 2 A 7 A
6 2 3
B B B
HI M2 M1 LO E
W–B
OFF
H41
Junction 17 IH3 (LHD)
LO 10 Connector E E 17 IH4 (RHD)
e1(A), e2(B)
PTC Heater
L
12 1 B 2 B
M1
1 13 W–B
W–B
M2
W–B
W–B
20 6C
W–B
2 eB3 1 eB3 (∗1)

HI
2 eB4 1 eB4 (∗2)
W–B
W–B
W–B
H14 1 8
Blower SW
(Front A/C)
W–B
W–B
22 6C 21 6C
L
W–B
L–R
L
L
A
L
B
L
C
W–B
W–B
W–B
B3 H1 B4 B3
F ro n t A ir C o n d itio n e r (2 T R – F E , 1 K D – F T V , 2 K D – F T V ) a n d P T C H e a te r (2 K D – F T V )
5 6 7 8
H18
A/C Amplifier
A. C LED+ BLW GND PRE S5 PS SG–1 TAM HR SPD ALT TE SG FRBV MHSW
8 9 16 29 4 13 21 12 25 6 36 37 24 31 22 38
B
(∗4)
(∗4)
B–W
Y
V
W
W
(∗4)
(∗4)
(∗3)
P–L
L–B
R–L
Y–R
R–B
G–B
L–W
W–B
G–W
28 HA1 27 HA1 12 HA1 4 HA1 14 HB1 5 HH1 6 HH1
3 HH1 4 HH1
B
(∗5)
(∗5)
B–W
Y
(∗5)
(∗5)
G–B
W
Y–R
L–W
G–W
Y
B
(∗4)
(∗4)
(∗4)
(∗4)
L–B
G–B
B–W
W
L–B
L–B
10 6D
V
Off
(∗3)
(∗3)
R–L
Y–R
Y–R
On
Alternator
< 2–4>
4 3 2 3 3 2 1 7 8 6
B AIND PR + + PR 6 6D 7 6D E B L
A14
Ambient Temp. Sensor
(∗6)
Combination SW
< 9–3>
11 6D 12 6D 2
Combination Meter
< 28–3>
(∗8)
(∗8)
– –
L–W
L–W
L–W
A4
A/C Pressure
Sensor No. 1
A26
A/C Pressure
Sensor No. 2
H8
Sensor (Front A/C)
1 1 2 8 6D 9 6D
36 HA1 (RHD) 21 HA1

L 3 HA1 (LHD)
(∗3)
(∗7)
L–B
L–B
L–B
L–W
L–W
Volume SW
2 H16
A/C SW
29 HB1 IG
L–W
H17 3 Off
L–O
Rear Window
Defogger SW
On
L–R
(∗7)
L–B
Max Hot SW
W–B
HIACE (EM04Z2E)
7 DB5
L–O
(∗7)
L–B
4 ∗ 6 : w/o Volume SW
8 6F
∗ 8 : w/ Volume SW
7. 5A A/C
1 6F
H34
Fuse Box
3
L
L–R
A
L
B L–B
L A
(∗7)
C
W–B
H2
M
387
30 HIACE (Cont' d)
388
F ro n t A ir C o n d itio n e r (2 T R – F E , 1 K D – F T V , 2 K D – F T V )
M u ltip le x C o m m u n ic a tio n S y s te m (C A N )
a n d P T C H e a te r (2 K D – F T V )
9 10 11 12
H23
(BAT) (IG) DLC3
∗ 9 : 2TR–FE
H18 10A 10A
A/C Amplifier ECU–B A/C
RRTE SG–2 RRAC RMGV LOCK MGC CANL CANH IG+ B CANH CANL
23 30 7 18 28 19 11 10 20 40 2 6 14
L
R
(∗7)
W–R
2 10 5M 28 5E
R
W
51 HB1
W
R–B
15 6E H3(A), H4(B), H5(C), H6(D)
(∗7)
R–B
R–B
Junction Connector
W–R
1 C 2 C
17 5E ST–Plug
L
(∗7)
7 2
14 6E
3
H42
Junction
Connector
(∗7)
(∗7)
R–B
R–B
3 DB5 4
3 5D

System< 32–5> < 32–6>
W–R
4 4
1
L
(∗7)
R–B
W–R
2 3 1 A 2 A 1 B 2 B 1 D
R
MG CLT
Relay
B
W
13 HB1
W–B
1 5
11 HB4 22 HB4
4 4
L
W
B
W
R
R
(∗9)
(∗7)
(∗7)
R–L
R
(∗7) 33 B 34 B (∗9)
24 B 23 B (∗7)
7 DB5 2 DB5 CANH CANL B7(B)
Engine ECU
W–B
HIACE (EM04Z2E)
CAN+ CAN–
(∗7)
R–L
22 B 21 B
1 5S
L
R
(∗7)
(∗7)
(∗9)
R–L
1 3 2 12 5E 7 5M
W–B
D13
A/C Compressor
1
12
D14
A/C Compressor
ECT and A/T Indicator
System< 8–3>
(∗9)
W–B
W–B
H41
Junction
Connector
(∗7)
L–B
L–B 3 DB5
A
(∗7)
W–B
(∗9)
W–B
B2 B3 H1
31 HIACE
F ro n t A ir C o n d itio n e r (5 L – E )
1 2 3 4
(BAT) (IG) (IG)
40A 10A ∗ 2 : Before Oct. 2006 Production, RHD From Oct. 2006 Production 10A
HTR GAUGE until Apr. 2009 Production A/C
∗ 4 : w/ Volume SW
2 1B L R–B
Off
10 5M 27 5B 28 5E
3 On 2
AIND L
R–B
R–B
B–R
R–B
R–B
L–W 1
1 5L 1 A (LHD)
4 B (RHD)
B
Engine ECU
< 6–5>
HI
4 H16
5 2 A/C SW
A5
Pressure SW
4 HTR 6 4
4
Relay
Y
(∗2)
R–B
G–W
H42
Junction
Connector
R–L
3 1 7
Y
(∗3)
29 HB1 51 HB1 3 HH1 28 HA1
R–B
R–B
12 5E 7 5M 7 5F 5 5Q
R–B
H1(A), (B)
Blower Resistor
(Front A/C)
4 4
Y
(∗2)
R–L
R–B
G–W
L
L
M2 M1 E
W–B
W–B
3 A 2 A 4 A (LHD) 8 10 11 13 3 2 3
2
2 B 3 B 1 B (RHD) AC1 ACT A. C IG+ PRE
M H19 MG CLT
Relay
A/C Amplifier
H2
Blower Motor
(Front A/C)
1 GND FRBV TE SG RRTE RRAC RMGV MGC
1 5
L–B
HIACE (EM04Z2E)
L–W
W–B
6 12 4 16 7 18 9 15
L–W
L–W L–W 4 4
R
W
L–B
B
(∗2)
6 2 3
R
R–L
13 HB1
HI M2 M1 LO E
W–B
9 6C 6 6D
5 HH1
OFF
L
L
B
(∗3)
LO 10
12 H41
Junction 10 6C 8 6C 8 6D 10 DB1
B
M1
(∗2)
20 6C 21 6C Connector
1 8 6F
W
M2
W–B
W
L–B
Rear Air Conditioner System
< 32–5> < 32–6>
HI
R–L
8 7
22 6C H14 1
1 8 B E
Blower SW 1 6F (∗1) 1
(Front A/C)
L
(∗4)
(∗4)
L
W–B
W–B
H8
Sensor (Front A/C)
W–B
2
D15
A/C Compressor
W–B
Volume SW
B3 H1 H2
H17
M
389
390
R e a r A ir C o n d itio n e r ∗ 3 : For production through approximately Dec. 2006
∗ 4 : For production from approximately Dec. 2006
1 2 3 4
(BAT) (IG) (BAT)
15A 10A 30A

RR HTR A/C RR CLR
L L
9 5M 10 5M 10 5S 28 5E 2 1C R–L R–L R–L R–L

(∗3)
L–R
L
L
R–B
Y–R
R–W
R–B
R–B
R–B
Y
R–L
10 5H 6 5D
6 VB1
10A Fuse
(In Line)
10A Fuse
(In Line)
R–G R
4 1 (∗4) (∗4)
1 1
R–W
RR HTR
H42
Junction
Connector
R–L(∗3)
R–L(∗4)
R–L(∗3)
R–L(∗4)
Relay 5 1
5
6 Vj1 2 B 2 B
4 RR CLR M M
Relay
R–B
j1(B)
Blower Motor
(Rear A/C LH)
j6(B)
Blower Motor
(Rear A/C RH)
R
1 B 1 B
R–W
(∗3)
(∗3)
L–R
R–G
3 2
25 5E 13 5D 4 3
GND Lo Me Hi
1 1 1 3 A 1 A 3 A 1 A
OFF 2
L–R
L–R
R–B
W–B
R–W
Lo
j2
Blower Resistor
(Rear A/C)
6 2 Me M M
Noise Filter
(In Line)
B IG Hi 4
L–R
2 A j1(A) 2 A j6(A)
j3 8 1 6 Blower Motor Blower Motor
Blower SW R–L (Rear A/C LH) (Rear A/C RH)
(Rear A/C)
(∗3)
B
(∗3)
(∗3)
L–W
L–W
W–B
W–B
W–B
W–B
R–Y
(∗4)
HIACE (EM04Z2E)
L
L W–B W–B W–B

H11 3
Rear Blower SW
(Main)
W–B
W–B
5 Vj1
4 Vj1
11 6F
L
W–B
5 VB1 2 VB1
10 6F
L
W–B
W–B
9 6F L
A
R–B
B
L–R
1 6F
C
W–B W–B
D
W–B
W–B
W–B
H2 B2 B3
32 HIACE (Cont' d)
R e a r A ir C o n d itio n e r
5 6 7 8
L L
∗ 1 : 2TR–FE, 1KD–FTV, 2KD–FTV
∗ 2 : 5L–E
1
L
H18(A), H19(B)
L
A/C Amplifier
RRTE SG SG–2 RRAC RMGV
23 A 30 A 7 A 18 A (∗1)
7 B 16 B 18 B 9 B (∗2)
2 3
(∗2)
L–B
W–R
Y
(∗2)
R–Y
k1
Blower Motor
(Rear Heater)
k2
Blower Resistor
(Rear Heater)
P(∗1)
1
6 6D
2
(∗1)
L–B
L
B
L–R
W–L
40 HB1 31 HB1
9 6D
1 kP1 2 kP1 3 kP1 4 kP1 (LHD)
1 kQ1 2 kQ1 3 kQ1 4 kQ1 (RHD)
(∗2)
L–B
R–Y
4
53 HB1 30 HB1
2 1
L
B
L–R
W–L
(RHD)
(RHD)
(RHD)
(RHD)
L–B
W–R
7. 5A
A/C NO. 3
B16
A/C Magnetic Valve
(Rear A/C)
L
B
L–R
W–L
4 VB1 (∗1) 3 VB1 (∗1) 1 QP1 2 QP1 3 QP1 4 QP1
(LHD)
(LHD)
(LHD)
(LHD)
2
3 VB1 (∗2) 4 VB1 (∗2) 1
L
B
L–R
W
W–L
(RHD)
(RHD)
(RHD)
(RHD)
(∗2)
W
(∗1)
(∗1)
L
R–B
B
(∗2)
HIACE (EM04Z2E)
1 BP1 2 BP1 5 BP1 6 BP1
3 Vj1 2 Vj1
L
B
L–R
W–L
W
1 6 1 4
HI M L E
OFF
j5
Sensor (Rear A/C)
Lo
2
Me
L
A Hi
R–B B24
B 8
Blower SW
L–R (Rear Heater)
C
W–B
W–B
D
M
391
392
P o w e r S lid e D o o r
1 2 3 4
p3
(BAT) Door Control SW (BAT) (BAT) (IG)
25A 10A 30A 7. 5A

PSD ECU–B RR DOOR ECU–IG
2 2 2
2 Lock Release Motor 2 2 11 5C

M
W
B–R
W–R
B–R
Initial
Position SW
Lock Release
Position SW
8 Bq1 6 HB4
B
B
R
R
GR
B–R
CSW– PSW– PSW+ CSW+ UL L 1
W
B34
3 1 2 4 6 5 Junction
Connector
1 Bq1 4 Bq1 3
16 oq1
B–R
BR
BR
4 Bq2
W
B–R
B–R
W–R
L
Y
B
R
q3(A), q4(B)
12 B 8 A Door Control Relay (Power Slide Door) 9 B
ECUB B IG
2 po1
RACT BZR+ GND GND CSW MSW

10 A 1 B 21 B 7 A 16 B 17 B
W
BR
W–B
P
B–Y
R–B
W–B
W–B
6 10 12 5 3 1 8 Bq2 9 Bq2
HIACE (EM04Z2E)
B E PSW CSW UL L 1 1
P
BZR+
B–Y
H41
Junction
Connector
GND RACT CLS

13
p2
Door Opening Relay
BZR– 10 HB4 21 HB4
2 4 11
q2
Slide Door
Warning Buzzer
2
P
W–B
B–Y
R–B
R–B
W–B
W–B
2 IH2 12 IH2 17 IH4
R–B
11 po1
P
B–Y
W–B
R–B
3 4
W–B
17 oq1
I12
Junction
Connector
12
3 oq1
R–B
I15
Power Slide Door
Control SW
I16
Power Slide Door
Main SW
4 5
W–B
W–B
W–B
W–B
W–B
W–B
W–B
8 po1 3 Bq1
W–B
W–B
p1 B3 H1
33 HIACE (Cont' d)
P o w e r S lid e D o o r
5 6 7 8
Park/Neutral
Position SW
< 7–7> < 8–7>
R–W
3
q1(A), Q5(B)
Slide Door Motor Assembly
Integration Relay
< 19–7>
H47
Magnetic Clutch Slide Door Sensor
2
Slide Door Motor
B–L
R–Y
Combination Meter
< 28–2>
9 HB4 20 HB4
SD+ GND SD– CL+ CL– DSV DS1 DS2 DSG
3 B 1 B 2 B 5 B 4 B 3 A 4 A 2 A 1 A
B–L
P–L
R–Y
10 Bq2 1 Bq2 2 Bq2
L
B
P
B
R
LG
BR
Y–B
Y–R
B–L
P–L
R–Y
q3(A), q4(B)
Door Control Relay (Power Slide Door) 7 B 6 B 26 B 4 A 9 A 3 A 5 A 1 A 11 B 24 B 23 B 10 B
P MPX1 SPD SD+ SEL SD– CL+ CL– DSV DS1 DS2 DSG
SGND HSW DC+ DC– POS POL HAF FUL DLSW OS

13 B 8 B 2 A 6 A 19 B 18 B 4 B 5 B 22 B 14 B
L
P
B
Y
G
BR
L–R
Y–G
L–W
G–W
HIACE (EM04Z2E)
9 oq1 1 oq1 13 oq1 12 oq1 7 oq1 6 oq1 11 oq1 10 oq1 8 oq1 2 oq1
L
P
B
Y
BR
L–R
Y–G
L–W
G
G–W
16 po1 6 po1 1 po1 10 po1 13 po1 4 po1 12 po1 3 po1 15 po1 7 po1
L
P
B
Y
G
BR
BR
L–R
Y–G
L–W
G–W
2 1 10 9 3 4 4 1 2
ACT+ ACT– HND POL HAF FUL OS OSG
1
Y
B
R
p5
Slide Door Lock
L
1
2 1
p4
Slide Door
Handle SW
M Handle SW
Initial
Position SW
2 p6
BR
Power Slide Door

Pawl
Position SW
Slide Door
W
Closer Motor Sensor
L
L
Latch SW
BR
L
E1
p1 8
Slide Door Lock Assembly
BR
BR BR BR
M
393
34 HIACE
394
O p tio n C o n n e c to r (T V S S ) O p tio n C o n n e c to r (P a rk in g A s s is t)
1 2 3 4
(BAT) (BAT) (IG)
H50
Option Connector
10A 15A 15A (Clearance Warning Buzzer)
Flasher Relay
< 11–3>
DOME TVSS IGN
2 2
2 2 1 5D BOR BOF
1 2
L–R
R
B–R
3 1
W
1
20 HB2
Door Lock Control SW

< 19–1> < 19–2>
H46
Junction
Connector
Back Door Courtesy SW
(15–7)
< 15–7>
Spiral Cable
< 12–4>
3 10 HB4 21 HB4
5A TRN L
5A TRN R
H51
Option Connector
(Fuse Box)
4 2
B
W
Back–Up Lamp SW
< 12–2>
L
Y
L–Y
L–Y
L–B
R–L
B–R
R–B
L–W
10 BT1 16 BT1
1 2 8 12 4 5 13 16 15
+B IG L1 UL1 CTYB CTYD HORN TRNR TRNL
B
P
H49
Option Connector (TVSS ECU) 10 TY2 9 TY2 8 TY2
B
P
SILN STA INDE IND SPD STB GND E1 E2

7 14 18 17 3 11 10 6 9
2 1 3
BGM1 BGM2 RB
BR
G–Y
B–W
W–B
W–B
W–B
W–B
HIACE (EM04Z2E)
15 HB4 4 HB4 12 IH2 2 IH2 5 HB4 14 HB4 13 HB4 2 HB4 E
Y4 4
Option Connector
BR
G–Y
B–W
W–B
W–B
W–B
W–B
Combination Meter
< 28–1>
1 1 4
W–B
SILN E LP
17 18 19
+B
B44
Option Connector
(TVSS Siren)
3 I19 16 B36
ST Relay
< 2–2>
Option Connector Junction
(TVSS Indicator Lamp) Connector
R
W–B
B3 B1 Y1

BMC Hiace

Uploaded by

Document Informationclick to expand document information

Document Informationclick to expand document information

Copyright:

Available Formats

BMC Hiace

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

BMC Hiace

Uploaded by

Copyright:

Available Formats

FOREWORD

This wiring diagram manual has been prepared to provide

This manual applies to the models listed below. It covers all

Applicable models: TRH201, 203, 213, 221, 223 Series

Refer to the following manuals for additional service

Manual Name Pub. No.

All information in this manual is based on the latest product

HOW TO USE THIS MANUAL . . . . . . . . . . . . . . . . . . B . . . . 3

GLOSSARY OF TERMS AND SYMBOLS . . . . . . E . . . . 18

ELECTRICAL WIRING ROUTING . . . . . . . . . . . . . . G . . . . 44

GROUND POINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . I . . . . 290

POWER SOURCE (Current Flow Chart) . . . . . . . J . . . . 302

CONNECTOR LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . K . . . . 310

PART NUMBER OF CONNECTORS . . . . . . . . . . . L . . . . 334

OVERALL ELECTRICAL WIRING DIAGRAM . . M . . . . 338

No. Section Description

INDEX Index of the contents of this manual.

HOW TO USE THIS

D ABBREVIATIONS Defines the abbreviations used in this manual.

INDEX Index of the system circuits.

This manual provides information on the electrical circuits installed on vehicles by

When the circuit operation is understood, begin troubleshooting of the problem

Rear Combination Lamp (LH)

[J] : Indicates the pin number of the connector.

[Q] : Relay Blocks

Code See Page Relay Blocks (Relay Block Location)

[R] : Junction Block and Wire Harness Connector

[S] : Connector Joining Wire Harness and Wire Harness

[T] : Ground Points

Code See Page Ground Points Location

Pressure SW Fog Lamp

Windshield Brake Fluid Level

J POWER SOURCE (Current Flow Chart)

Battery 30A AM2 2 Fusible Link Block 6 10A HAZARD

100A ALT 6 60A ABS 5

Engine Room R/B (See Page 20)

[B] : Junction Connector

Junction connector in this manual include a short terminal which is

[C] : Parts Code

[D] : Connector Color

L PART NUMBER OF CONNECTORS

A3 Air Flow Meter 90980–12292 B24 Blower SW (Rear Heater) 90980–10463

A5 Pressure SW 90980–10943 B26 Door Courtesy SW (Front RH) 90980–12470

A9 Brake Vacuum Warning SW 90980–11252 B30 Fuel Filter Warning SW 90980–11003

A12 Airbag Sensor (Front RH) 90980–11856 B34 Junction Connector

A13 Airbag Squib B35 Junction Connector 90980–11398

[A] : Part Code

[B] : Part Name

[C] : Part Number

CONTINUITY AND RESISTANCE CHECK

DISCONNECTION OF MALE AND FEMALE

Press Down Press Down

Example: Up 3. DISENGAGE THE SECONDARY LOCKING DEVICE OR

(a) Locking device must be disengaged before the terminal

[A] For Non–Waterproof Type Connector

HINT : The needle insertion position varies according to the

[Retainer at Temporary Lock Position]