3546 LI Max.
28W
Charger for Li-ion batteries - switch mode
• 3-step charge control with current detection
• Universal input voltage (90-264 VAC)
• Wake up and low current start-up
of deeply discharged batteries
• Error indication for reverse polarity, short circuit,
charging battery packs with wrong number of
cells and safety timer run-out
• With NTC input on request
• Order plugs and mains cord separately
• ECO-design compliance:
DoE and CEC
• Approvals:
- Medically certified
Safety: EN 60601-1 ed. 3.1
EMC: EN 60601-1-2 ed. 4
- UL approved
For updates: see www.mascot.no
TECHNICAL SPECIFICATIONS MEDICAL
GENERAL INPUT/OUTPUT SAFETY PROTECTION EMC
Input voltage: 90-264 VAC Protection: Protected against reversed
Line Frequency: 47 – 63Hz polarity and short circuit proof
Switch frequency, approx.: 40 kHz Insulation class: Class II
Leakage current from batt. Insulation voltage
with mains switched off: <0,4mA @ nominal Primary – secondary: 4000VAC / 5700VDC
battery voltage Electrical safety std: EN/IEC 60335-2-29,
Temperature range EN/IEC/ANSI 60601-1
• Operating: -25 °C - +40 °C EMC standards
• Storage: -25 °C - +85 °C • Medical EN 60601-1-2
Ripple: < 100 mV p-p • Emission EN 55014-1, EN 61000-6-3
Dimensions (L×W×H): 124 × 50 × 37 mm • Immunity EN 55014-2, EN 61000-6-1
Weight: 220g Input terminal: 2-pin IEC 60320 connector C8
Output terminals: DC connector, battery clips,
push on terminals or open ends
IP-code: 4X
VERSIONS
Step 0 < 10min Step 0 > 10min Step 1 Step 2 Step 3
CHARGE CONTROL
(yellow) (Red: 4 blinks) (yellow) (Flash yellow) (green)
Max output Low Current start-up for Charge term
Cells Battery voltage too low Charge Current Charge Voltage Restart
power (W) deeply discharged batt. when current is:
CC 100mA±25mA
2 23W 2.5A ±0.3A 8.4V ±0.1V 8.2V
when batt. < 6V
CC 100mA±25mA
3 28W 2.2A ±0.2A 12.6V ±0.1V 12.3V
when batt. < 9V
CC 100mA±25mA < 100mA
4 28W 0A/0V 1.6A ±0.15A 16.8V ±0.1V 16.4V
when batt. < 12V or max. 1 hr.
CC 100mA±25mA
7 29W 1.0A ±0.1A 29.4V ±0.2V 28.7V
when batt. < 21V
CC 100mA±25mA
10 29W 0.7A ±0.07A 42V ±0.3V 41V
when batt. < 30V
www.mascot.com [email protected]
Main Office NORWAY Mascot UK Mascot DE, BENELUX Mascot DE, CH, AT Mascot FRANCE Mascot BALTIC, RUSSIA Mascot SWEDEN
Box 177 Bok 2090, Salisbury Hirschbergstr. 28/7 Tettnanger Str. 52 38 rue Leo Lagrange Taevakivi 15 Box 177 TS170619
N-1601 Fredrikstad Wiltshire SP2 2BH D-74838 Limbach D-88239 Wangen F-94270 Le Kremlin Bicêtre 13619 Tallinn, Estonia N-1601 Fredrikstad
Mascot
+ 47 69AS
36Headquarters
43 00 • PO172
+44 Box250
1774853
• 1601 Fredrikstad
+49 628 795NORWAY
140 • +47 69752
+49 36 43
895001677
• [email protected]
+33 146 587•185
www.mascot.no+372 555 21 121 +46 526 14025
Charging characteristics and LED indication *
Diagram: E
INDICATOR:
INDICATOR: YELLOW FLASHING YELLOW INDICATOR: GREEN
Charge Voltage Battery Voltage
No voltage,
Battery Voltage no current
from charger!
Charge Current
Cut-Off Current No current (0A)
Start Current
Low Current Start-Up at Vbatt <3V/cell
Error Mode if <3V/cell after 10 minutes
Step 0 Step 1 Step 2 Step 3
Start Timer
(10 min)
CC Charge CV Charge (max1 h) Charge complete
Safety Timer (72 hours)
LiIon charger diagram
* an animated video of this charging progress is available on our website
BATTERY NOT CONNECTED INDICATIONS
Battery not connected is indicated by FLASHING GREEN. In this mode charger
will apply short pulses attempting to wake up deeply discharged batteries.
ERROR INDICATIONS
2 red blinks: Battery is connected to charger with wrong polarity!
3 red blinks: Charger output is shorted. Check output cable connection!
4 red blinks: Battery voltage is low. Check battery status or voltage.
5 red blinks: Safety timer has run out. Check battery status or capacity.
LED off: Battery voltage is too high. Check battery voltage.
WAIT MODE INDICATIONS
Yellow with 1 red blink: Battery temperature is too low (<0°C)
Yellow with 2 red blink: Battery temperature is too high (>45°C)
www.mascot.com [email protected]
Main Office NORWAY Mascot UK Mascot DE, BENELUX Mascot DE, CH, AT Mascot FRANCE Mascot BALTIC, RUSSIA Mascot SWEDEN
Box 177 Bok 2090, Salisbury Hirschbergstr. 28/7 Tettnanger Str. 52 38 rue Leo Lagrange Taevakivi 15 Box 177 TS170619
N-1601 Fredrikstad Wiltshire SP2 2BH D-74838 Limbach D-88239 Wangen F-94270 Le Kremlin Bicêtre 13619 Tallinn, Estonia N-1601 Fredrikstad
Mascot
+ 47 69AS
36Headquarters
43 00 • PO172
+44 Box250
1774853
• 1601 Fredrikstad
+49 628 795NORWAY
140 • +47 69752
+49 36 43
895001677
• [email protected]
+33 146 587•185
www.mascot.no+372 555 21 121 +46 526 14025
Exchangeable AC plugs
EU plug adapter US plug adapter
Part no. 127000 Part no. 127100
Weight: 20,9 g Weight: 13,4 g
UK plug adapter AUS plug adapter
Part no. 127200 Part no. 127300
Weight: 29,2 g Weight: 21,4 g
2-pin IEC 60320 C7 mains cord
1800 mm
EU part no. 131306, UK part no. 131148,
US part no. 131368, AU part no. 013108
124 mm
50mm
37mm
www.mascot.com [email protected]
Main Office NORWAY Mascot UK Mascot DE, BENELUX Mascot DE, CH, AT Mascot FRANCE Mascot BALTIC, RUSSIA Mascot SWEDEN
Box 177 Bok 2090, Salisbury Hirschbergstr. 28/7 Tettnanger Str. 52 38 rue Leo Lagrange Taevakivi 15 Box 177 TS170619
N-1601 Fredrikstad Wiltshire SP2 2BH D-74838 Limbach D-88239 Wangen F-94270 Le Kremlin Bicêtre 13619 Tallinn, Estonia N-1601 Fredrikstad
Mascot
+ 47 69AS
36Headquarters
43 00 • PO172
+44 Box250
1774853
• 1601 Fredrikstad
+49 628 795NORWAY
140 • +47 69752
+49 36 43
895001677
• [email protected]
+33 146 587•185
www.mascot.no+372 555 21 121 +46 526 14025
