SERVICE DATA SHEET

Tiger XR, XRT, XRX, XC, XCA, XCX

Brakes
Brake disc maximum run out . . . . . . . . . . . . . . . Front 0.15 mm - Rear 0.5 mm
Brake disc minimum thickness . . . . . . . . . . . . . . Front 4.0 mm - Rear 5.0 mm
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . DOT 4

Master Cylinders
Front brake - Tiger XR, XRT, XRX Front brake - Tiger XC, XCA, XCX Rear brake all models

25 Nm
25 Nm 15 Nm

25 Nm

7 Nm

25 Nm
16 Nm
25 Nm 25 Nm 25 Nm

Calipers and Brake Pads

Front brake All Models Rear brake

1.5 mm 1.5 mm
6 Nm

21 Nm 18 Nm
3 Nm
3 Nm
6 Nm
18 Nm
M8 - 22 Nm
M12 - 27 Nm
Engine and Lubrication
Oil. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Semi or fully synthetic 10W/40 or 10W/50 engine oil which meets specification API SH (or higher)
and JASO MA. Triumph recommends Castrol Power 1 Racing 4T 10W/40 or 10W/50 (fully synthetic)
engine oil, sold as Castrol Power RS Racing 4T 10W/40 or 10W/50 (fully synthetic) in some countries
Oil quantity. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3.6 litres (oil and filter change). Always refer to the check sight glass for the correct level
Coolant type. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Triumph HD4X Hybrid OAT coolant (premixed as supplied by Triumph)
Coolant capacity . . . . . . . . . . . . . . . . . . . . . . . . . . 2.69 litres
Grease. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Grease to NLGI 2 specification
Camshaft cover bolts . . . . . . . . . . . . . . . . . . . . . . Lubricate the seals for the camshaft cover bolts with clean engine oil
Camshaft cover tightening sequence . . . . . . . . Tighten the camshaft cover bolts in the sequence shown below

3 1-7 10 Nm 6
Inlet
0.100 - 0.200 mm

10 Nm
25 Nm
Exhaust
0.325 - 0.375 mm
5 2-8 10 Nm 4
Fuel and Air

1.5 Nm
1 Nm

12 Nm 12 Nm

18.1 Page updated 02.2017

SERVICE DATA SHEET - continued
Final Drive and Clutch
Chain lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . Chain spray suitable for O-ring chains

319 mm 15 Nm 110 Nm
Maximum Length

20 Links

10 - 20 kg 20 - 30 mm 2 - 3 mm

Battery and Ignition

Charge rate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Must not exceed 1.4 A (refer to the Service Manual)

12 Nm

12 V - 14 Ah

NGK CR9EK 0.7 mm

Suspension and Wheels
Tiger XR, XRT, XRX Tiger XC, XCA, XCX
Recommended fork oil grade Showa SS8 (SAE10W) WP 4860-1166 SAE4
Oil volume (dry fill) 553 cc 479 cc
Oil level (fork fully compressed) 103 mm 111 mm

Tiger XR, XRT, XRX 90 Nm Tiger XC, XCA, XCX 90 Nm

110 Nm 65 Nm 110 Nm 65 Nm
110 Nm 110 Nm

22 Nm 22 Nm

2.90 bar (42 lb/in²) 2.48 bar (36 lb/in²) 2.90 bar (42 lb/in²) 2.48 bar (36 lb/in²)

Tyre Pressure (Off Road Use Only) . . . . . . . . . . Refer to the Owner’s Handbook

Service Parts Information

Parts Information Description Odometer Reading in Miles (kms), Time Period

500 / (800) Annual 6,000 12,000 24,000

1 month (10,000) (20,000) (40,000)
18,000
(30,000)

For current parts Sump Plug Washer • • • • •

information, refer to
the Electronic Parts Oil Filter • • • • •
Catalogue Air Cleaner • •
Spark Plug • •
Camshaft Cover Seal • •
Camshaft Cover Screw Seal • •
Drive Chain Rubbing Strip • • •
Front Brake Pad Set - Tiger 800 As necessary

Rear Brake Pad Set As necessary

Standard Service Time Allowance (Hrs.) 1.50 1.75 3.25 4.50 5.25

Page updated 02.2017 18.2