VEHICLE INSPECTION CHECKLIST

Vehicle Identification Number

Date Inspection Completed:

M M D D Y Y
Inspected by:
(Print Name)
Dealer Code:
Directions: Start by completing the basic header information, then Year Model Mileage
continue using this worksheet to guide you through the Mitsubishi /
Motor's Certified Preowned Vehicle Inspection Process.

Note: Not all equipment is available on all vehicles Standards Standards

Met - 'OK' 'Not' Met Reason(s) 'Not' Meeting Standards After Repair
Records / Books
1 Model year and mileage within program guidelines
2 Original warranty book/owner's manual in glove box
3 Verify correct VIN plate on dash pad, B'-pillar VIN, and
bulkhead VIN stamping - (VIN's are all matching)
Road Test
Engine Operation 4 Idle speed smooth and within specifications
5 Engine performs normally while driving-varying speeds
6 Smooth when cold, during warm-up, and after warm-up
Brakes/Clutch 7 Brake and parking brake function normally
8 Clutch pedal height and free play at specifications
Transmission 9 Automatic Transmission shifts properly in all gears
(A/T-Automatic, M/T-Manual) 10 Manual Transmission shifts properly in all gears
Speedometer/Odometer/Tachometer 11 Functions properly
Cruise Control 12 Functions properly
Steering 13 Steering operation is normal
14 Steering wheel centered
Noise or Vibration 15 None present
Squeaks, Rattles and Wind Noise 16 None present
AWD 17 Check operations
Wheel Balance 18 Check for any wheel vibrations at highway speeds
Engine Performance 19 Check for good engine response at various rpm's
Interior Technical
Interior Front Compartment 20 Check interior front compartment for excessive interior
damage/abnormal wear (including floor mats)
Outside/Inside Rear View Mirrors 21 Power mode functions properly
22 Outside mirror heater functions properly
23 Rear view mirror/dimmer functions properly
Keys 24 Vehicle has (2) master keys
Remote Keyless Entry Devices 25 (2) remote entry transmitters-operation of devices: lock and
unlock doors along with the trunk/lift gate & PHEV charge door

Security System 26 Check function of the security system (if equipped)

Seat Belts 27 Extend, retract smoothly and buckle properly
28 No twists, cuts, signs of wear-locks/unlocks smoothly
29 Verify seatbelt anchors are in place
Seats 30 Fore and aft functions properly
31 Recline and headrest adjustments operate properly
32 Memory operates properly (driver's side if equipped)
Power Windows/Locks 33 Functions properly
Air Conditioner (A/C) and Heater 34 Climate control system functions properly (all modes)
35 Check for any unusual odors
36 Rear defogger operation functions properly
37 Check automatic A/C mode functions (if equipped)
38 Check A/C cooling performance (cools cabin)
Horn 39 Horn operates properly
Steering Wheel 40 Tilt functions properly
Windshield Wipers 41 Windshield wiper operation (front and rear)
42 Wiper blades clear glass properly
43 Washer check (front and rear)
Dashboard Lights 44 Check all warning lights, indicators, and gauges
Lights 45 Check all interior lights for proper operation
Audio System 46 Radio functions
47 Antenna

1
Note: Not all equipment is available on all vehicles Standards Standards
Met - 'OK' 'Not' Met Reason(s) 'Not' Meeting Standards After Repair

Audio System (continued) 48 Check for CD operation (if applicable)

49 Radio functions (scan, seek, rewind, fast forward) operate
properly
50 Check for proper speaker output
51 Check steering remote control switch operation (if equipped)

Sunroof 52 Power sunroof operates properly

53 Wind deflector operates properly
54 Sunroof shade slides smoothly
Clock 55 Functions properly
Cigarette Lighter/Accessory Sockets 56 Functions properly
Glove Box 57 Door and lock operates properly
Exterior Technical
Convertible Top 58 Check operation and inspect for stains, rips, tears, etc
Body 59 Inspect for overall appearance and physical damage
Lights 60 Exterior lights function and illuminate properly
61 Verify lens/covers condition are free of defects
Door Lock System 62 Doors open and close smoothly using interior/exterior door
handles
63 Verify doors cannot be opened when lock button is in lock
position
64 Child safety locks operate properly
65 Verify key entry locks & fuel door release operate properly

Trunk Release 66 Operates properly from inside the vehicle

67 Check trunk closing effort for proper operation
Luggage Compartment/Spare 68 Spare tire size, condition, and air pressure (at specs)
69 Spare tire properly installed and secured with wheel lock key in
place
70 Spare tire cover, jack, tire repair kit, and jack tools secured in
Tire and Jack Assembly place
71 Luggage trim and mat are properly installed
72 Verify emergency trunk release works properly
Under Hood
Hood Release 73 Operates properly
Engine Hood Prop 74 Verify hood prop/hanger condition operates properly
Fluid levels - Mitsubishi standards 75 Engine oil (engine not running)
76 Brake
77 Clutch (if equipped)
78 Power steering
79 Engine coolant
80 Washer (front and rear-if equipped)
81 Automatic transmission (per Owner's Manual)
Battery / Terminals / PHEV Drive Battery 82 No damage/leakage / perform load test (min. 12.4V) / charging
properly
Wires and Hoses 83 No signs of being loose, excessive wear, and damage
Engine Fan 84 Functions properly
Engine Drive Belts 85 No signs of being loose, excessive wear and damage
Under Vehicle
Leaks 86 Check for leaks at the following locations:
Radiator
Engine and oil pan
Transmission bell housing, case, and pan
Manual transmission/transaxle
Transfer case (4WD)
Front axle, strut, and shock absorbers
Steering rack, control arms, and linkage
Frame rails and undercarriage
Drive shaft boots, CV joints and differential assembly
Exhaust system and catalytic converter
Rear suspension components
Brake hydraulic system
Automatic transmission/transaxle
PHEV listed items

Fluids (proper levels) 87 Manual transmission/transaxle fluid

88 Check transfer case (if applicable)
89 Differential transaxle lubricant
Wheels 90 Check for surface damage - wheels and center caps
2
Note: Not all equipment is available on all vehicles Standards Standards
Met - 'OK' 'Not' Met Reason(s) 'Not' Meeting Standards After Repair
Tire Pressure (including spare) 91 Set at recommended specifications

Tires (minimum tread depth = 5/32") 92 Inspect for nails, screws, and foreign objects
93 L/F:________/32" R/F:________/32"
L/R:________/32" R/R:________/32"

Brake Inspection 94 L/F:______/_______mm R/F:_______/______mm

(pad material is greater than 4 mm) 95 L/R:______/_______mm R/R:_______/_____mm

(shoe material is greater than 2 mm)
96 Rotors show no signs of excessive wear, rust, warpage or heat

97 Calipers, lines, and hoses show no sign of excessive wear,

leakage, or rust
98 Parking brake assemblies, cables/attaching hardware show no
sign of excessive wear, damage, or rust
Chassis Inspection 99 Frame rails and floor pan
(no signs of damage/excessive wear) 100 Engine mounts and oil pan
101 Transmission/transaxle case and pan
102 Shocks, struts, and springs
103 Fuel lines, fuel tank, hoses, and protectors
104 Differential assembly, drive shaft, and related components

105 Drive shaft boots and CV joints

106 Steering rack, linkage, bushings, control arms, and dust boots

107 All chassis bolts for looseness and damage

Maintenance
108 Oil and filter changed and chassis lubed (as required)
109 Regularly scheduled service brought to current standards if
within 2,000 miles (re: Owner's Manual) and no open Recalls.

Final Detailing
110 Steam clean under the hood
111 Detail engine compartment
112 Wash exterior; check for water leaks immediately after
washing, check weather stripping and rubber moldings
113 Sunroof water tested - verify no leaks
114 Remove spare tire and detail trunk compartment - dress and re-
install spare tire
115 Inspect all body panels/glass for damage and proper alignment

116 Inspect all painted surfaces for damage and finish quality

117 Inspect wheels and tires

118 Wax/buff exterior and apply wheel dressing
119 Clean and detail interior
120 Check interior panel and trim fit
121 Check for stains, dirt, scuffs, and tears
122 Complete/sign the Certified Preowned Vehicle Inspection

Certified Pre-Owned Information 123 Dealer must “register” vehicle as a Certified Pre-Owned
Vehicle on the Mitsubishi Dealer Link (MDL).

I herby certify that all Technical Inspection items have been checked and any necessary repairs or adjustments have been indicated on the worksheet for the vehicle above in accordance with the
standards of the Certified Preowned Vehicle Inspection Program.
Date:
Inspector Signature: M M D D Y Y

Lancer Ralliart, Lancer Sportback Ralliart, Lancer Evolution, & i-MiEVs are NOT eligible under
the CPO Program