福田零部件图册

(TD824-1F161F23K)

福田雷沃重工国际贸易有限公司
TD824-1F161F23K拖拉机

目录 CONTENTS
序号 代码 名称 页次
No. Code Description Page

1 1004C-P4TRT82N02-20 10-发动机总成 10-ENGINE ASSEMBLY 1

2 1004C-P4TRT82N02-19 10-发动机总成 10-ENGINE ASSEMBLY 3
3 1004C-P4TRT82N02-15 10-发动机总成 10-ENGINE ASSEMBLY 5
4 1004C-P4TRT82N02-14 10-发动机总成 10-ENGINE ASSEMBLY 7
5 1004C-P4TRT82N02-09 10-发动机总成 10-ENGINE ASSEMBLY 9
6 1004C-P4TRT82N02-04 10-发动机总成 10-ENGINE ASSEMBLY 11
7 1004C-P4TRT82N02-23 10-发动机总成 10-ENGINE ASSEMBLY 15
8 1004C-P4TRT82N02-18 10-发动机总成 10-ENGINE ASSEMBLY 19
9 1004C-P4TRT82N02-13 10-发动机总成 10-ENGINE ASSEMBLY 21
10 1004C-P4TRT82N02-08 10-发动机总成 10-ENGINE ASSEMBLY 23
11 1004C-P4TRT82N02-03 10-发动机总成 10-ENGINE ASSEMBLY 25
12 1004C-P4TRT82N02-22 10-发动机总成 10-ENGINE ASSEMBLY 27
13 1004C-P4TRT82N02-17 10-发动机总成 10-ENGINE ASSEMBLY 29
14 1004C-P4TRT82N02-12 10-发动机总成 10-ENGINE ASSEMBLY 31
15 1004C-P4TRT82N02-07 10-发动机总成 10-ENGINE ASSEMBLY 35
16 1004C-P4TRT82N02-02 10-发动机总成 10-ENGINE ASSEMBLY 39
17 1004C-P4TRT82N02-21 10-发动机总成 10-ENGINE ASSEMBLY 43
18 1004C-P4TRT82N02-16 10-发动机总成 10-ENGINE ASSEMBLY 45
19 1004C-P4TRT82N02-11 10-发动机总成 10-ENGINE ASSEMBLY 47
20 1004C-P4TRT82N02-06 10-发动机总成 10-ENGINE ASSEMBLY 49
21 1004C-P4TRT82N02-01 10-发动机总成 10-ENGINE ASSEMBLY 51
22 1004C-P4TRT82N02-24 10-发动机总成 10-ENGINE ASSEMBLY 53
23 1004C-P4TRT82N02-05 10-发动机总成 10-ENGINE ASSEMBLY 55
24 1004C-P4TRT82N02-10 10-发动机总成 10-ENGINE ASSEMBLY 57
25 1004-4TRT82-N02-1 10.1-气缸体 CYLINDER BLOCK 59

1
 TD824-1F161F23K拖拉机

目录 CONTENTS
序号 代码 名称 页次
No. Code Description Page

26 1004-4TRT82-N02-10 10.10-起动电机 STARTING MOTOR 61

27 1004-4TRT82-N02-11 10.11-风扇驱动装置 FAN DRIVE FBH00001 63
28 1004-4TRT82-N02-12 10.12-润滑油底壳-12 LUBRICATING OIL SUMP 65
29 1004-4TRT82-N02-13 10.13-加油口盖板 FILLER COVER PLATE 69
30 1004-4TRT82-N02-14 10.14-气缸盖罩 CYLINDER COVER 71
31 1004-4TRT82-N02-15 10.15-机油滤清器及机油冷却器 LUBRICATING OIL FILTER & OIL COOLER 73
32 1004-4TRT82-N02-17 10.17-水泵及节温器-17 WATER PUMP & THERMOSTAT 75
33 1004-4TRT82-N02-18 10.18-水出口及入口-18 WATER OUTLET & INLET 79
34 1004-4TRT82-N02-19 10.19-交流发电机及发电机 ALTERNATOR & GENERATOR 81
35 1004-4TRT82-N02-2 10.2-正时齿轮及凸轮轴 TIMING GEAR& CAMSHAFT 83
36 1004-4TRT82-N02-20.1 10.20.1-空气压缩机-20.1 AIR COMPRESSOR 87
37 1004-4TRT82-N02-20.2 10.20.2-空气压缩机-20.2 AIR COMPRESSOR 89
38 1004-4TRT82-N02-21 10.21齿轮驱动/转向助力选用 GEAR DRIVE AUXILIARY DRIVE OPTION 91
39 1004-4TRT82-N02-22.1 10.22.1-进排气系统-22.1 MANIFOLDS & EXHAUST SYSTEM 93
40 1004-4TRT82-N02-22.2 10.22.2-进排气系统-22.2 MANIFOLDS & EXHAUST SYSTEM 95
41 1004-4TRT82-N02-23 10.23-燃油滤清器及油管-23 FUEL FILTER AND PIPE 99
42 1004-4TRT82-N02-24 10.24-输油泵和盖板-24 LIFT PUMP AND BLANKING PLATES 101
43 1004C-P4TRT82N02-25 10.25-发动机总成-25 ENGINE ASSEMBLY-25 103
44 1004-4TRT82-N02-25 10.25-发动机提升 ENGINE LIFTING 105
45 1004C-P4TRT82N02-26 10.26-发动机总成-26 ENGINE ASSEMBLY-26 107
46 1004-4TRT82-N02-26 10.26支撑 MOUNTINGS 109
47 1004C-P4TRT82N02-27 10.27-发动机总成-27 ENGINE ASSEMBLY-27 111
48 1004-4TRT82-N02-27 10.27-放水阀 DRAIN VALVE 113
49 1004C-P4TRT82N02-28 10.28-发动机总成-28 ENGINE ASSEMBLY-28 115
50 1004-4TRT82-N02-28 10.28-垫及垫片（顶部维修组件） JOINTS & GASKETS-TOP SERVICE KIT 117

2
TD824-1F161F23K拖拉机

目录 CONTENTS
序号 代码 名称 页次
No. Code Description Page

51 1004C-P4TRT82N02-29 10.29-发动机总成-29 ENGINE ASSEMBLY-29 119

52 1004-4TRT82-N02-29 10.29-垫及垫片（底部维修组件） JOINTS & GASKETS-BOTTOM SERVICE KIT 121
53 1004-4TRT82-N02-3 10.3-曲轴活塞及连杆-3 CRANKSHAFT PISTONS & CONNECTING RODS 123
54 1004-4TRT82-N02-4 10.4-气缸盖 CYLINDER COVER 125
55 1004-4TRT82-N02-5 10.5-摇臂轴 ROCKER SHAFT 129
56 1004-4TRT82-N02-6 10.6-润滑油泵-6 LUBRICATING OIL PUMP 131
57 1004-4TRT82-N02-7.1 10.7.1-燃油喷射系统-7.1 FUEL INJECTION EQUIPMENT 133
58 1004-4TRT82-N02-7.2 10.7.2-燃油喷射系统-7.2 FUEL INJECTION EQUIPMENT 135
59 1004-4TRT82-N02-8 10.8-飞轮板 FLYWHEEL PLATE 139
60 1004-4TRT82-N02-9 10.9-飞轮及启动齿圈 FLYWHEEL & STARTER RING 141
61 TD800.11B 11-空气滤清系总成 11-AIR CLEANER ASSEMBLY 143
62 TD800.131 13.1-冷却系总成 13.1-COOLING SYSTEM ASSEMBLY 145
63 TD800.132A 13.2-支架安装总成 13.2-BRACKET INSTALLATION ASSEMBLY 147
64 TD800.201 20.1-手油门操纵总成 20.1-HAND THROTTLE CONTROL ASSSEMBLY 149
65 TA700.202 20.2-脚油门总成 20.2-FOOT THRORRLE ASSEMBLY 151
66 TD800.203C 20.3-拉线总成 20.3-PULL WIRE ASSEMBLY 153
67 FT800.21C.001 21-离合器总成 21-CLUTCH ASSEMBLY 155
68 FT800A.21C.002-1 21.1-离合器操纵总成-1 CLUTCH CONTROL ASSEMBLY-1 157
69 FT800A.21C.002-2 21.2-离合器操纵总成-2 CLUTCH CONTROL ASSEMBLY-2 161
70 FT800A.21C.002-3 21.3-离合器操纵总成-3 CLUTCH CONTROL ASSEMBLY-3 165
71 TD804.311 31.1-前桥总成 31.1-FRONT AXLE ASSEMBLY 169
72 TD804.312 31.2-托架总成 31.2-BRACKET ASSEMBLY 171
73 TD800.313A 31.3-托架前体总成 31.3-BRACKET FRONT BODY ASSEMBLY 173
74 FT804B.32.001 32-前驱动轮总成 32-FRONT DRIVING WHEEL ASSEMBLY 175
75 FT800.34B.001 34-后驱动轮总成 34-REAR DRIVE WHEEL ASSEMBLY 177

3
 TD824-1F161F23K拖拉机

目录 CONTENTS
序号 代码 名称 页次
No. Code Description Page

76 FT800.35.001 35-牵引装置总成 35-TOWING MECHANISM ASSEMBLY 179

77 TD800A.371C 37.1-变速箱壳体总成 37.1-GEARBOX HOUSING ASSEMBLY 181
78 TD800A.372G-1 37.2.1-主副变速总成-1 MAIN/ASSISTANT GEAR ASSEMBLY-1 183
79 TD800A.372G-2 37.2.2-主副变速总成-2 MAIN/ASSISTANT GEAR ASSEMBLY-2 185
80 TD800A.372G-3 37.2.3-主副变速总成-3 MAIN/ASSISTANT GEAR ASSEMBLY-3 187
81 TD800A.372G-4 37.2.4-主副变速总成-4 MAIN/ASSISTANT GEAR ASSEMBLY-4 189
82 TD800A.373B-1 37.3.1-侧置操纵总成-1 SIDE CONTROL ASSEMBLY-1 193
83 TD800A.373B-2 37.3.2-侧置操纵总成-2 SIDE CONTROL ASSEMBLY-2 195
84 TD800A.373B-3 37.3.3-侧置操纵总成-3 SIDE CONTROL ASSEMBLY-3 199
85 TD800A.374B 37.4-爬行档机构总成 37.4-CREEPER GEAR MECHANISM ASSEMBLY 201
86 TD804A.38-1 38.1-后桥箱总成-1 REAR AXLE CASE ASSEMBLY-1 205
87 TD804A.38-2 38.2-后桥箱总成-2 REAR AXLE CASE ASSEMBLY-2 207
88 TD804A.38-3 38.3-后桥箱总成-3 REAR AXLE CASE ASSEMBLY-3 211
89 TD804A.38-4 38.4-后桥箱总成-4 REAR AXLE CASE ASSEMBLY-4 213
90 TD804A.38-5 38.5-后桥箱总成-5 REAR AXLE ASSEMBLY-5 215
91 FT800.39.002 39-右最终传动总成 39-RIGHT FINAL TRANSMISSION ASSEMBLY 217
92 FT800.39.001 39-左最终传动总成 39-LEFT FINAL TRANSMISSION ASSEMBLY 221
93 FT804A.40A.001-1 40.1-全液压转向总成-1 40FULL HYDRAULIC STEERING ASSEMBLY-1 225
94 FT804A.40A.001-2 40.2-全液压转向总成-2 40FULL HYDRAULIC STEERING ASSEMBLY-2 229
95 TD800.411C 41.1-动力输出轴总成 41.1-PTO SHAFT ASSEMBLY 233
96 TD800.412A-1 41.2.1-动力输出齿轮总成-1 PTO GEAR ASSEMBLY-1 235
97 TD800.412A-2 41.2.2-动力输出齿轮总成-2 PTO GEAR ASSEMBLY-2 237
98 TD800.413 41.3-动力输出操纵机构总成 41.3-PTO CONTROL MECHANISM ASSEMBLY 239
99 TD800.414B 41.4-动力输出防护罩总成 41.4-PTO BONNET INSTALLATION ASSEMBLY 243
100 FT804A.42.001-1 42.1-分动箱总成-1 TRANSFER CASE ASSEMBLY-1 245

4
TD824-1F161F23K拖拉机

目录 CONTENTS
序号 代码 名称 页次
No. Code Description Page

101 FT804A.42.001-2 42.2-分动箱总成-2 TRANSFER CASE ASSEMBLY-2 247

102 FT804A.42.001-3 42.3-分动箱总成-3 42TRANSFER CASE ASSEMBLY -3 249
103 FT804A.42.001-4 42.4-分动箱总成-4 TRANSFER CASE ASSEMBLY-4 253
104 FT800A.43C.001 43-制动系总成 43-BRAKE SYSTEM ASSEMBLY 255
105 FT800A.43C.001-1 43.1-制动系总成-1 43BRAKING SYSTEM ASSEMBLY-1 257
106 FT800A.43C.001-2 43.2-制动系总成-2 43BRAKING SYSTEM ASSEMBLY-2 259
107 FT800A.43C.001-3 43.3-制动系总成-3 43BRAKING SYSTEM ASSEMBLY-3 261
108 FT800A.43C.001-4 43.4-制动系总成-4 43BRAKING SYSTEM ASSEMBLY-4 263
109 FT800A.43C.001-5 43.5-制动系总成-5 43BRAKING SYSTEM ASSEMBLY-5 265
110 FT800A.43C.001-6 43.6-制动系总成-6 43BRAKING SYSTEM ASSEMBLY-6 267
111 FT800A.43C.001-7 43.7-制动系总成-7 BREAKE SYSTEM ASSEMBLY-7 269
112 FT800A.44.001 44-座椅安装总成 44SEAT INSTALLATION ASSEMBLY 271
113 TD800.452J-1 45.2.1-地板总成-1 FLOOR ASSEMBLY-1 273
114 TD800.452J-2 45.2.2-地板总成-2 FLOOR ASSEMBLY-2 277
115 TD800.454A 45.4-操纵盖板总成 45.4-CONTROLLING COVER PLATE ASSEMBLY 279
116 TD800.456A 45.6-仪表台装配总成 45.6-DASHBOARD INSTALLATION ASSEMBLY 281
117 TD800.457 45.7-前连接装置总成 45.7-FRONT CONNECTION EQUIPMENT ASSEMBLY 283
118 TD800.458A 45.8-后连接装置总成 45.8--REAR CONNECTING EQUIPMENT ASSEMBLY 285
119 FT800A.46.001 46-安全架总成 46-SAFETY FRAME ASSEMBLY 287
120 TD800.471A-1 47.1.1-机罩总成-1 BONNET ASSEMBLY-1 289
121 TD800.471A-2 47.1.2-机罩总成-2 BONNET ASSEMBLY-2 293
122 TD800.472B 47.2-机罩下围板总成 47.2-BONNET LOW PLATE ASSEMBLY 295
123 TD800.472A 47.2-机罩下围板总成 47.2-BONNET LOW PLATE ASSEMBLY 297
124 TD800.474A 47.4-机罩锁操纵总成 47.4-BONNET LOCK CONTROL ASSEMBLY 299
125 TD800.474B 47.4-机罩锁操纵总成 47.4-BONNET LOCK CONTROL ASSEMBLY 301

5
 TD824-1F161F23K拖拉机

目录 CONTENTS
序号 代码 名称 页次
No. Code Description Page

126 TD800.475C 47.5-机罩密封装配总成 47.5-BONNET SEAL INSTALLATION ASSEMBLY 303

127 TD900.481A 48.1-发动机线束安装总成 48.1-ENGINE HARNESS INSTALLATION ASSEMBLY 305
128 TD900.482D 48.2-车身线束安装总成 48.2-BODY HARNESS INSTALLATION ASSEMBLY 307
129 TD800.483A 48.3-前灯线束安装总成 48.3-FRONT LAMP HARNESS INSTALLATION 311
130 TD900.484 48.4-后灯线束安装总成 48.4-REAR LAMP HARNESS INSTALLATION ASSEMBLY 313
131 TD800.485A 48.5-蓄电池安装总成 48.5-BATTERY INSTALLATION ASSEMBLY 315
132 TD800.487 48.7-组合仪表总成 48.7-COMBINED INSTRUMENT ASSEMBLY 317
133 FT300.49.001 49-工具箱总成 49-TOOL BOX ASSEMBLY 319
134 TD800.501A 50.1-主油箱总成 50.1-MAIN OIL TANK ASSEMBLY 321
135 TD800.502 50.2-副油箱总成 50.2-AUXILIARY OIL TANK ASSEMBLY 323
136 TD800.503C 50.3-进出油管总成 50.3-OIL INLET/OUTLET PIPE ASSEMBLY 325
137 TD800.55D-1 55.1-提升器装置总成-1 LIFT INSTALLATION ASSEMBLY-1 327
138 TD800.55D-2 55.2-提升器装置总成-2 LIFT INSTALLATION ASSEMBLY-2 331
139 TD800.55D-3 55.3-提升器装置总成-3 LIFT INSTALLATION ASSEMBLY-3 335
140 TD800.55D-4 55.4-提升器装置总成-4 LIFT INSTALLATION ASSEMBLY-4 339
141 FT800.56.001a-1 56.1-悬挂机构总成-1 SUSPENSION MECHANISM ASSEMBLY-1 343
142 FT800.56.001a-2 56.2-悬挂机构总成-2 SUSPENSION MECHANISM ASSEMBLY-2 345
143 FT800.56.001a-3 56.3-悬挂机构总成-3 SUSPENSION ASSEMBLY-3 347
144 TD800.57C-1 57.1-分配器装配总成-1 DISTRIBUTOR INSTALLATION ASSEMBLY-1 349
145 TD800.57C-2 57.2-分配器装配总成-2 DISTRIBUTOR INSTALLATION ASSEMBLY-2 353
146 TD800.57C-3 57.3-分配器装配总成-3 DISTRIBUTOR INSTALLATION ASSEMBLY-3 355
147 TD800.57C-4 57.4-分配器装配总成-4 DISTRIBUTOR INSTALLATION ASSEMBLY-4 357
148 FT804A.58H.001 58-油泵油管滤油器总成 58-OIL PUMP/PIPE/FILTER ASSEMBLY 359
149 TD904.582A-1 58.2.1-多路阀油管总成-1 MULTI-WAY VALVE OIL PIPE ASSEMBLY-1 363
150 TD904.582A-2 58.2.2-多路阀油管总成-2 MULTI-WAY VALVE OIL PIPE ASSEMBLY-2 365

6
TD824-1F161F23K拖拉机

目录 CONTENTS
序号 代码 名称 页次
No. Code Description Page

151 TD800.583A 58.3-单路液压输出总成 58.3-SINGLE-WAY HYDRAULIC OUTPUT ASSEMBLY 369

152 TA600.62ZC 62-安全带 62-SAFETY BELT 371
153 FT800.74B.001 74-前配重总成 74-FRONT BALLAST ASSEMBLY 373
154 FT800.74B.002 74-前配重架总成 74-FRONT BALLAST BRACKET ASSEMBLY 375
155 FT800.91B.001 91-后配重总成 91-REAR BALLAST ASSEMBLY 377
156 TD804.311-1 前桥总成-1 31FRONT AXLE ASSEMBLY-1 379
157 TD804.311-2 前桥总成-2 31FRONT AXLE ASSEMBLY-2 381
158 TD804.311-3 前桥总成-3 31FRONT AXLE ASSEMBLY-3 385
159 TD804.311-4 前桥总成-4 31FRONT AXLE ASSEMBLY-4 389
160 TD804.311-5 前桥总成-5 31FRONT AXLE ASSEMBLY-5 391
161 1004-4TRT82-N02-16 前端驱动输入 FRONT END DRIVE INPUT 393

7
TD824-1F161F23K拖拉机

8
TD824-1F161F23K拖拉机

1
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-20 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T74501036 发电机 GENERATOR 1 2012-08_

10 T3827H025B 发电机支架 GENERATOR BRACKET 1 2012-08_
11 T3753V014A 调节杆 ADJUSTING ROD 1 2012-08_
12 T3753V016 支架 SUPPOT BRACKET 1 2012-08_
13 T2314H018 螺栓 BOLT 1 2012-08_

13 T2314H018 螺栓 BOLT 1 2012-08_

15 T2314J004 螺栓 BOLT 1 2012-08_
16 T64502110 隔圈 1 2012-08_
17 T2314H002 螺栓 BOLT 4 2012-08_
19 T2314J003 螺栓 BOLT 1 2012-08_

2 T2314H007 螺栓 BOLT 1 2012-08_

3 T2314H008 螺栓 BOLT 1 2012-08_
4 T0920497 垫圈 WASHER 2 2012-08_
5 Q340B08 螺母M8 NUT M8 2 2012-08_
5 Q340B08 螺母M8 NUT M8 2 2012-08_

6 Q40308 弹性垫圈8 SPRING WASHER 8 2 2012-08_

7 T2314J006 螺栓 BOLT 1 2012-08_
8 T2131A010 垫圈10 WASHER 10 2 2012-08_
9 T2318A634 螺母 NUT 1 2012-08_

2
TD824-1F161F23K拖拉机

3
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-19 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3684A004 节温器壳垫 GASKET 1 2012-08_

2 T3771K043 出水口 Water outlet 1 2012-08_
4 T2314H010 螺栓 BOLT 1 2012-08_
5 T2314H008 螺栓 BOLT 1 2012-08_

4
TD824-1F161F23K拖拉机

5
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-15 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T74105021 机油滤清器滤芯 OIL FILTER ELEMENT 1 2012-08_

10 T74202012 油冷器(16片) OIL COOLING 1 2012-08_
11 T34821121 弯胶管 BENDING HOSE 1 2012-08_
12 T74202031 油冷器回水管 OIL COOLER WATER RETURN PIPE 1 2012-08_
13 T74202003 接头 CONNECTING JOINT 1 2012-08_

14 T2481877A 卡箍 CLAMP HOOP 4 2012-08_

15 T64202014 油冷器接头 CONNECTION 1 2012-08_
17 T4126E068G 油冷器进水管 PIPE、 WATER INLET 1 2012-08_
18 T3385H001 连接胶管 CONNECTING RUBBER PIPE 1 2012-08_
2 T2314J008 螺栓 BOLT 1 2012-08_

3 T2314J018 螺栓 BOLT 1 2012-08_

4 T2314J040 螺栓 BOLT 1 2012-08_
5 T2314J048 螺栓 BOLT 1 2012-08_
6 T3773T101A 垫板 PAD BOARD 1 2012-08_
7 T3686T006 垫 WASHER 2 2012-08_

8 T3773P312A 机滤器滤座 HEAD、LUB. OIL 1 2012-08_

9 T33554128A 接头 CONNECTING JOINT 1 2012-08_

6
TD824-1F161F23K拖拉机

7
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-14 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3681A021A 缸盖罩垫 CYL. HEAD COVER JOINT 1 2012-08_

10 T3573A006B 支架 SUPPOT BRACKET 1 2012-08_
2 T3687A507A 防尘条 SEAL 1 2012-08_
2 T3687A507A 防尘条 SEAL 1 2012-08_
3 T4142X046G 缸盖罩总成 CYLINDER COVER BONNET ASSEMBLY 1 2012-08_

4 T3274A003 螺母 NUT 3 2012-08_

5 T0920009 垫圈 WASHER 3 2012-08_
6 T33817135 密封圈 SEAL RING 3 2012-08_
7 T4133J001 呼吸器总成 1 2012-08_
8 T33881108E 呼吸管 BREATH PIPE 1 2012-08_

9 T0180064A 喉箍 HOOP 1 2012-08_

8
TD824-1F161F23K拖拉机

9
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-09 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T63640800K1 飞轮部 FLYWHEEL ASSEMBLY 1 2012-08_

4 T2185103 螺栓 BOLT 10 2012-08_
5 T33117127 垫圈 WASHER 10 2012-08_
6 GBT276-6303-2Z 深沟球轴承 BEARING 1 2012-08_

10
TD824-1F161F23K拖拉机

11
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-04 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3681E033D 缸盖垫 CYLINDER HEAD GASKET 1 2012-08_

10 T0650710 碗堵 COREHOLE PLUG 1 2012-08_
11 T32417121 出沙孔堵 PLUG 4 2012-08_
11 T32417121 出沙孔堵 PLUG 4 2012-08_
12 T3343F041A 气门导管 VALVE STEM GUIDE 4 2012-08_

13 T3343J021A 气门导管 VALVE STEM GUIDE 4 2012-08_

13 T3343J021A 气门导管 VALVE STEM GUIDE 4 2012-08_
14 T2114A046 定位销 THIMBLE 2 2012-08_
15 T32166219 螺栓 BOLT 8 2012-08_
16 T32166221 螺栓 BOLT 12 2012-08_

17 T32166222 螺栓 BOLT 2 2012-08_

18 T3142L072 进气门 AIR INLET VALVE 4 2012-08_
19 T33817117B 密封圈 SEAL RING 4 2012-08_
2 T3712H074Z 缸盖(总成) CYLINDER HEAD 1 2012-08_
20 T31745122 气门弹簧 VALVE SPRING 4 2012-08_

21 T31744133 气门弹簧 VALVE SPRING 4 2012-08_

22 T33415118 垫圈 WASHER 4 2012-08_
23 T33424107 气门座 VALVE SEAT 4 2012-08_
24 T33173108 气门锁夹 LOCK 8 2012-08_
25 T3142A051 排气门 EXHAUST VALVE 4 2012-08_

3 T3712H074 气缸盖 CYLINDER COVER 1 2012-08_

4 T3324E003 进气门座 AIR INLET VALVE SEAT 4 2012-08_
4 T3324E003 进气门座 AIR INLET VALVE SEAT 4 2012-08_
5 T3314A122 排气门座 INSERT-VALVE SEAT(OUTLET) 4 2012-08_
6 T0650586 螺堵 SCREW PLUG 4 2012-08_

12
TD824-1F161F23K拖拉机

13
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-04 10-发动机总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

6 T0650586 螺堵 SCREW PLUG 4 2012-08_

7 T0650203 堵 PLUG 1 2012-08_
8 T2431154 堵 PLUG 2 2012-08_
9 T2411157 垫圈 WASHER 1 2012-08_

14
TD824-1F161F23K拖拉机

15
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-23 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T848010043 增压器 TURBOCHARGER 1 2012-08_

10 T3688C023 垫 WASHER 1 2012-08_
11 T3778H201A 排气管 EXHAUST PIPE 1 2012-08_
12 T2313C078 双头螺柱 8.8-A3L STUD 3 2012-08_
13 Q340B10T13F2 螺母 NUT 3 2012-08_

14 Q40310 弹簧垫圈 SPRING WASHER 3 2012-08_

15 T64703009 密封垫片 SEAL WASHER 1 2012-08_
16 T747160007 排气弯管 EXHAUST BENDING PIPE 1 2012-08_
16 T747160007 排气弯管 EXHAUST BENDING PIPE 1 2012-08_
17 T3683D008 垫 WASHER 1 2012-08_

18 T3571N007 油管 PIPE 1 2012-08_

19 T2314H003 螺栓 BOLT 2 2012-08_
2 TL681VF03 垫 WASHER 1 2012-08_
20 T3383A006 胶管 RUBBER HOSE 1 2012-08_
21 T2481877A 卡箍 CLAMP HOOP 1 2012-08_

22 T3571N008 油管 PIPE 1 2012-08_

23 T36832144 垫 WASHER 1 2012-08_
25 T0201502 接头 CONNECTING JOINT 1 2012-08_
26 TL311KF01 垫圈 WASHER 1 2012-08_
27 T4123T016B 油管 PIPE 1 2012-08_

3 TL254HF03A 丝对 STUD 4 2012-08_

4 T2318A633 螺母 NUT 4 2012-08_
5 T748070053 防护罩 SHIELD 1 2012-08_
6 T2314F001 螺栓 BOLT 2 2012-08_
7 T2313M387A 丝对 STUD 3 2012-08_

16
TD824-1F161F23K拖拉机

17
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-23 10-发动机总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

8 T2313M388A 丝对 STUD 1 2012-08_

9 T2318A634 螺母 NUT 4 2012-08_

18
TD824-1F161F23K拖拉机

19
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-18 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3684A004 节温器壳垫 GASKET 1 2012-08_

2 T3771K043 出水口 Water outlet 1 2012-08_
3 T2314H008 螺栓 BOLT 4 2012-08_

20
TD824-1F161F23K拖拉机

21
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-13 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T0650586 螺堵 SCREW PLUG 1 2012-08_

1 T0650586 螺堵 SCREW PLUG 1 2012-08_
10 35-76D38X3.1 密封圈 SEAL RING 1 2012-08_
2 T3617A001 板 PLATE 1 2012-08_
3 T3683H006A 垫 WASHER 1 2012-08_

4 T2314H003 螺栓 BOLT 2 2012-08_

5 T74001001 加油口 FILLING CAP 1 2012-08_
6 T74001202 加油口盖 COVER 1 2012-08_
7 T3683H006 垫 WASHER 1 2012-08_
8 T2314H010 螺栓 BOLT 1 2012-08_

9 T2314H007 螺栓 BOLT 1 2012-08_

22
TD824-1F161F23K拖拉机

23
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-08 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T73631004C 飞轮板 FLYWHEEL PLATE 1 2012-08_

10 Q40316 垫圈 WASHER 4 2012-08_
11 Q40312 弹簧垫圈 SPRING WASHER 2 2012-08_
2 T73606004 飞轮板定位套 FLYWHEEL PLATE LOCATING BUSH 2 2012-08_
3 T36843154 密封条 SEAL STRIP 1 2012-08_

4 T73631005 盖板 COVER PLATE 1 2012-08_

5 Q150B0610Q 螺栓 BOLT 2 2012-08_
6 Q40306 弹簧垫圈 SPRING WASHER 2 2012-08_
7 T2314J204 螺栓 BOLT 6 2012-08_
8 T0350025 飞轮壳定位销 FLYWHEEL HOUSING DOWEL PIN 2 2012-08_

9 GB5783-M12X45 螺栓 BOLT 2 2012-08_

24
TD824-1F161F23K拖拉机

25
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-03 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T31315681 曲轴 CRANK SHAFT 1 2012-08_

2 T81558 主轴瓦 MAIN BEARING 1 2012-08_
3 TZZ90001 止推片总成 THRUST SHIM ASSEMBLY 1 2012-08_
4 T3135J186A 活塞 PISTON 4 2012-08_
5 T4181A026 活塞环总成 PISTON RING ASSEMBLY 4 2012-08_

6 T3313T005 活塞销 PISTON PIN 4 2012-08_

7 T2721332 卡簧 CIRCLIP 8 2012-08_
8 T4115C211 连杆 CONNECTING ROD 4 2012-08_
8 T4115C211 连杆总成 CONNECTING ROD ASSEMBLY 4 2012-08_
9 T31132011 轴瓦 BEARING 4 2012-08_

26
TD824-1F161F23K拖拉机

27
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-22 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3777E221B 进气歧管 INTAKE MANIFOLD 1 2012-08_

10 T3684N009 垫 WASHER 1 2012-08_
11 T2314H004 螺栓 BOLT 4 2012-08_
12 T3766P052C 进气弯管 AIR INLET SYPHON 1 2012-08_
13 T0180069A 环箍 Clip 2 2012-08_

14 T3383E008 胶管 RUBBER HOSE 1 2012-08_

2 T3688C024 垫 WASHER 1 2012-08_
3 T2314J011 螺栓 BOLT 1 2012-08_
4 T2314J004 螺栓 BOLT 4 2012-08_
5 T2314J018 螺栓 BOLT 1 2012-08_

6 T73306108 油管 PIPE 1 2012-08_

7 T33225412 螺母 NUT 1 2012-08_
8 T3381A002 橄榄体 OLIVE 1 2012-08_
9 T2666108A 火焰预热塞 FLAME WARM-UP PLUG 1 2012-08_

28
TD824-1F161F23K拖拉机

29
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-17 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3685R005 垫 WASHER 1 2012-08_

17 T2415H494 O 型圈 O-RING 1 2012-08_
18 T2314H015 螺栓 BOLT 1 2012-08_
19 T2314H043 螺栓 BOLT 3 2012-08_
2 T3623K007 盖板 COVER PLATE 1 2012-08_

20 T2314H006 螺栓 BOLT 1 2012-08_

22 T74405005 节温器 THERMOSTAT 2 2012-08_
23 T3685F005 垫 WASHER 1 2012-08_
24 T744030025 节温器壳体 THERMOSTAT HOUSING BODY 1 2012-08_
25 T2431154 堵 PLUG 1 2012-08_

28 T2314J013 螺栓 BOLT 2 2012-08_

3 T2314H002 螺栓 BOLT 1 2012-08_
30 T2314H008 螺栓 BOLT 2 2012-08_
32 T3764E061 接头 CONNECTING JOINT 1 2012-08_
32 T3764E061 接头 CONNECTING JOINT 1 2012-08_

33 T3683N004 垫 WASHER 1 2012-08_

34 T2314H004 螺栓 BOLT 2 2012-08_
35 T33854114 胶管 RUBBER HOSE 1 2012-08_
36 T0180067A 卡箍 CLAMP HOOP 2 2012-08_
4 T2314H003 螺栓 BOLT 1 2012-08_

6 T2314J002 螺栓 BOLT 2 2012-08_

7 T4131E011C 水泵 WATER PUMP 1 2012-08_

30
TD824-1F161F23K拖拉机

31
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-12 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T738060002 桥架 AXLE FRAME 1 2012-08_

11 T2314H015A 螺栓 BOLT 10 2012-08_
12 T2314H012A 螺栓 BOLT 2 2012-08_
13 T2314K213 螺栓 BOLT 2 2012-08_
13 T2314K213 螺栓 BOLT 2 2012-08_

14 Q150B1645Q 螺栓 BOLT 4 2012-08_

15 T3575A046 吸油管 OIL SUCTION PIPE 1 2012-08_
16 T36832137 垫 WASHER 1 2012-08_
17 T2314H007 螺栓 BOLT 2 2012-08_
18 T3821D012 支架 SUPPOT BRACKET 1 2012-08_

19 T2314H002 螺栓 BOLT 1 2012-08_

2 T2311D039 螺栓 BOLT 2 2012-08_
20 T0920484 垫圈 WASHER 1 2012-08_
20 T0920484 垫圈 WASHER 1 2012-08_
21 T3661V002 板 PLATE 1 2012-08_

22 T3661C002 卡子 CLIP 1 2012-08_

23 T2314F002 螺栓 BOLT 1 2012-08_
24 T2314F004 螺栓 BOLT 1 2012-08_
24 T2314F004 螺栓 BOLT 1 2012-08_
25 T2318A602 螺母 NUT 2 2012-08_

26 T3577A125 油尺管 OIL DIPSTICK PIPE 1 2012-08_

27 T33812116 橄榄体 OLIVE 1 2012-08_
28 T3178C076 油尺 OIL DISTICK 1 2012-08_
3 T63802001A 油底壳 OIL SUMP 1 2012-08_
4 T2431A016 堵 PLUG 1 2012-08_

32
TD824-1F161F23K拖拉机

33
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-12 10-发动机总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

5 T32186405A 油底堵 OIL SUMP PLUG 2 2012-08_

6 T2415715 O 型圈 O-RING 2 2012-08_
7 T36815736 油底垫 OIL SUMP GASKET 1 2012-08_
8 T2314H055A 螺栓 BOLT 2 2012-08_
8 T2314H055A 螺栓 BOLT 2 2012-08_

9 T2314H023A 螺栓 BOLT 4 2012-08_

34
TD824-1F161F23K拖拉机

35
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-07 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 Q1201030F3S 双头螺柱 8.8-A3L STUD 4 2012-08_

13 T73302131 喷油器总成 INJEKTOR ASSEMBLY 4 2012-08_
14 T3662K002 压板 PRESSURE PLATE 4 2012-08_
15 T0921173 垫圈 WASHER 4 2012-08_
15 T0921173 垫圈 WASHER 4 2012-08_

16 T2314H006 螺栓 BOLT 8 2012-08_

17 T33813129 垫圈 WASHER 4 2012-08_
18 T33813131 防尘套 DUST COVER 4 2012-08_
19 T73208141 高压油管 HIGH PRESSURE OIL HOSE 1 2012-08_
2 T2318A604 螺母 NUT 4 2012-08_

20 T3558X043 油管 PIPE 1 2012-08_

21 T3218R005 过油螺栓 BOLT 3 2012-08_
22 T3355V002 过油螺栓 BOLT 1 2012-08_
23 T2411101 垫圈 WASHER 8 2012-08_
23 T2411101 垫圈 WASHER 8 2012-08_

24 T73214101 油管 PIPE 1 2012-08_

25 T4126E081C 进气补偿管 PIPE 1 2012-08_
26 T33225412 螺母 NUT 1 2012-08_
27 T33811112 橄榄体 OLIVE 1 2012-08_
28 T0201047 弯管 BENDING PIPE 1 2012-08_

28 T0201047 弯管 BENDING PIPE 1 2012-08_

3 T3117L113G 直列泵齿轮 STRAIGHT PUMP GEAR 1 2012-08_
4 T832080135 喷油泵 OIL INJECTION PUMP 1 2012-08_
5 T33828118B 垫 WASHER 1 2012-08_
6 T63274204 支撑板 SUPPORTING BOARD 1 2012-08_

36
TD824-1F161F23K拖拉机

37
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-07 10-发动机总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

7 T73208301 喷油泵支架 SUPPORT AS. 1 2012-08_

7 T73208301 支架 SUPPOT BRACKET 1 2012-08_
8 Q150B1025Q 螺栓 BOLT 2 2012-08_

38
TD824-1F161F23K拖拉机

39
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-02 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3681P009 垫 WASHER 1 2012-08_

12 T2314H013 螺栓 BOLT 6 2012-08_
13 T62204002 垫 WASHER 1 2012-08_
14 T62204001 检查盖 INSPECTION COVER 1 2012-08_
14 T62204001 检查盖 INSPECTION COVER 1 2012-08_

15 T2314F036 螺栓 BOLT 4 2012-08_

16 T0500012 键 KEY 1 2012-08_
17 T3117C061 齿轮 GEAR 1 2012-08_
18 T33426161A 轮毂 HUB 1 2012-08_
18 T33426161A 轮毂 HUB 1 2012-08_

19 T4111A013 齿轮 GEAR 1 2012-08_

2 T3716C133A 正时齿轮室 TIMING CASE 1 2012-08_
20 T3241H009 固定板 FIXED PLATE 1 2012-08_
21 T2314J010 螺栓 BOLT 3 2012-08_
22 T4111A021 齿轮 GEAR 1 2012-08_

23 T33123125 垫圈 WASHER 1 2012-08_

24 T2722A206 卡簧 CIRCLIP 1 2012-08_
24 T2722A206 卡簧 CIRCLIP 1 2012-08_
25 T31415364 凸轮轴 CAMSHAFT 1 2012-08_
26 T33153121 止推板 PLATE;THRUST 1 2012-08_

27 T2116053 销子 PIN 1 2012-08_

29 T3117L023 齿轮 GEAR 1 2012-08_
3 T2314H003 螺栓 BOLT 8 2012-08_
30 T2314J606 螺栓 BOLT 1 2012-08_
31 T3321A003 垫圈 WASHER 1 2012-08_

40
TD824-1F161F23K拖拉机

41
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-02 10-发动机总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

31 T3321A003 垫圈 WASHER 1 2012-08_

4 T2314H004 螺栓 BOLT 4 2012-08_
5 T3681P034 正时室盖垫 FRONT COVER JOINT 1 2012-08_
6 T3716M091B 前盖 FRONT COVER 1 2012-08_
7 T2418F436 油封 OIL SEAL 1 2012-08_

8 T2314H005 螺栓 BOLT 10 2012-08_

9 T2314H034 螺栓 BOLT 1 2012-08_

42
TD824-1F161F23K拖拉机

43
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-21 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3272X021 轮毂 HUB 1 2012-08_

2 T2415H213 O型圈 O-RING 1 2012-08_
3 T3117C161 齿轮 GEAR 1 2012-08_
4 T2551A289 轴承 BEARING 1 2012-08_
5 T3241H011 固定板 FIXED PLATE 1 2012-08_

6 T2314H002 螺栓 BOLT 3 2012-08_

7 T3753R241 支架 SUPPOT BRACKET 1 2012-08_
8 T2311D081 螺栓 BOLT 3 2012-08_
9 T2311D560 螺栓 BOLT 4 2012-08_

44
TD824-1F161F23K拖拉机

45
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-16 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3115T051B 皮带轮 BELT WHEEL 1 2012-08_

2 T3241N001 止推块 THRUST BLOCK 1 2012-08_
3 T711050047 螺栓 BOLT 3 2012-08_

46
TD824-1F161F23K拖拉机

47
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-11 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T4113H058 风扇驱动壳 FAN DRIVING HOUSING 1 2012-08_

2 T2314J014 螺栓 BOLT 4 2012-08_
3 T63910002A 皮带轮 BELT WHEEL 1 2012-08_
4 T64401006 皮带 BELT 2 2012-08_
5 T64406007 风扇叶片 FAN BLADE 1 2012-08_

6 T744070007 风扇垫块 FAN GASKET 1 2012-08_

7 T2314K166 螺栓 BOLT 4 2012-08_
8 Q40308 弹性垫圈8 SPRING WASHER 8 4 2012-08_

48
TD824-1F161F23K拖拉机

49
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-06 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T4132F056C 机油泵 OIL PUMP 1 2012-08_

2 T2314H005 螺栓 BOLT 3 2012-08_
3 T4138A049 限压阀总成 PRESSURE LIMITING VALVE ASSEMBLY 1 2012-08_
4 T2314J011 螺栓 BOLT 1 2012-08_
5 T3748C011 发兰 FLANGE 1 2012-08_

6 T2314H004 螺栓 BOLT 2 2012-08_

7 T2415H201 O 型圈 O-RING 2 2012-08_
8 T3343F012 油管 PIPE 1 2012-08_

50
TD824-1F161F23K拖拉机

51
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-01 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TZZ50265 机体（总成） CYLINDER BLOCK ASSEMBLY 1 2012-08_

10 T32418124 碗堵 COREHOLE PLUG 1 2012-08_
11 T31134165 衬套 SLEEVE 1 2012-08_
12 T32416119 堵 PLUG 1 2012-08_
13 T32417134 堵 PLUG 1 2012-08_

14 T64404002 堵 PLUG 1 2012-08_

15 T0650588 堵 PLUG 1 2012-08_
16 T32168212 堵 PLUG 1 2012-08_
17 T714030009 垫圈 WASHER 1 2012-08_
18 T4138A017 冷却喷嘴阀 PISTON COOLING JET 4 2012-08_

19 T3861A027 冷却喷嘴总成 COOLING NOZZLE ASSEMBLY 4 2012-08_

20 T721050003 后油封 REAR OIL SEAL 1 2012-08_
21 T3211C002 螺栓 BOLT 6 2012-08_
3 T3135X062 缸套 CYLINDER LINER 4 2012-08_
4 T32166329 大瓦螺栓 BOLT 10 2012-08_

5 T3271H004A 介轮轴 SHAFT 1 2012-08_

6 T3774A004 挺杆腔堵 PLUG 4 2012-08_
7 T33142111 定位套 LOCATING SLEEVE 10 2012-08_
8 T32418122 碗堵 COREHOLE PLUG 6 2012-08_
9 T0650710 碗堵 COREHOLE PLUG 6 2012-08_

52
TD824-1F161F23K拖拉机

53
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-24 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T75004251 燃油滤清器滤芯 FUEL FILTER STRAINER CORE 1 2012-08_

10 T75004276 支架 SUPPOT BRACKET 1 2012-08_
11 T2314J002 螺栓 BOLT 2 2012-08_
12 T73306109 回油管 OIL RETURN PIPE 1 2012-08_
13 T33225412 螺母 NUT 2 2012-08_

14 T33811112 橄榄体 OLIVE 2 2012-08_

15 T733080001 油管 PIPE 1 2012-08_
17 T73306106 回油管 OIL RETURN PIPE 1 2012-08_
19 T0650204 堵 PLUG 1 2012-08_
2 T0095344A 过油螺栓 BOLT 1 2012-08_

20 T73274309 密封垫圈 SEAL RING 1 2012-08_

3 T73217019 接头 CONNECTING JOINT 1 2012-08_
4 T73208144 垫圈 WASHER 2 2012-08_
5 T0576113 螺母 NUT 1 2012-08_
6 T0566004 橄榄体 OLIVE 1 2012-08_

7 T65005001A 油管 PIPE 1 2012-08_

8 T2314J005 螺栓 BOLT 2 2012-08_
9 T2318A604 螺母 NUT 2 2012-08_

54
TD824-1F161F23K拖拉机

55
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-05 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T2313H331 双头螺柱 8.8-A3L STUD 3 2012-08_

10 T31744123 弹簧 SPRING 2 2012-08_
11 T31743108 弹簧 SPRING 2 2012-08_
12 T33117434 垫圈 WASHER 2 2012-08_
13 T0170151 卡簧 CIRCLIP 2 2012-08_

14 T3818X901 支架 SUPPOT BRACKET 4 2012-08_

15 T3775E012 接头 CONNECTING JOINT 1 2012-08_
16 T2233022 螺栓 BOLT 1 2012-08_
17 T3311K015 垫片 WASHER 2 2012-08_
18 T33811113 橄榄体 OLIVE 1 2012-08_

19 T3142U031 挺柱 TAPPET 8 2012-08_

19 T3142U031 挺柱 TAPPET 8 2012-08_
2 T2318A605 螺母 NUT 3 2012-08_
20 T31434307 推杆 PUSH ROD 8 2012-08_
3 T2314J607 螺栓 BOLT 1 2012-08_

4 T31411124 摇臂轴 ROCKER SHAFT 1 2012-08_

5 T0650507 堵 PLUG 2 2012-08_
6 T4115R306 左摇臂 LEFT ROCKER 4 2012-08_
7 T4115R305 右摇臂 RIGHT ARM SHAFT 4 2012-08_
8 T32114145 调节螺钉 ADJUSTING SCREW 8 2012-08_

9 T0576052 螺母 NUT 8 2012-08_

56
TD824-1F161F23K拖拉机

57
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-10 10-发动机总成 10-ENGINE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T2313C078 双头螺柱 8.8-A3L STUD 3 2012-08_

2 Q340B10 螺母 NUT 3 2012-08_
3 Q40310 弹簧垫圈 SPRING WASHER 3 2012-08_
4 T73701009 起动马达 STARTING MOTOR 1 2012-08_

58
TD824-1F161F23K拖拉机

59
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-1 10.1-气缸体 CYLINDER BLOCK

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TZZ50265 机体（总成） CYLINDER BLOCK ASSEMBLY 1 2011-11_

10 T32418124 碗堵 COREHOLE PLUG 1 2011-11_
11 T31134165 衬套 SLEEVE 1 2011-11_
12 T32416119 堵 PLUG 1 2011-11_
13 T32417134 堵 PLUG 1 2011-11_

14 T64404002 堵 PLUG 1 2011-11_

15 T32168212 堵 PLUG 1 2011-11_
16 T72101002 垫圈 WASHER 1 2011-11_
17 T0650588 堵 PLUG 1 2011-11_
18 T4138A017 冷却喷嘴阀 PISTON COOLING JET 4 2011-11_

19 T3861A027 冷却喷嘴总成 COOLING NOZZLE ASSEMBLY 4 2011-11_

2 T3711H121 机体 BLOCK 1 2011-11_
20 T2418F701 后油封 REAR OIL SEAL 1 2011-11_
21 T3211C002 螺栓 BOLT 6 2011-11_
22 T3211C002 螺栓 BOLT 4 2011-11_

3 T3135X062 缸套 CYLINDER LINER 4 2011-11_

4 T32166329 大瓦螺栓 BOLT 10 2011-11_
5 T3271H004 惰轮轴 IDLER SHAFT 1 2011-11_
6 T3774A004 挺杆腔堵 PLUG 4 2011-11_
7 T33142111 定位套 LOCATING SLEEVE 10 2011-11_

8 T32418122 碗堵 COREHOLE PLUG 6 2011-11_

9 T0650710 碗堵 COREHOLE PLUG 6 2011-11_

60
TD824-1F161F23K拖拉机

61
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-10 10.10-起动电机 STARTING MOTOR

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 TZZ90156 马达前端壳 MOTOR FRONT COVER 1 2011-11_

0 TZZ90153 碳刷 CARBON BRUSH 1 2011-11_
0 T73701019 吸力开关 SUCTION SWITCH 1 2011-11_
0 T73701020 单项器 ONE-WAY VALVE MECHANISM 1 2011-11_
0 T63701013 轴衬组件 BUSHING UNIT 1 2011-11_

1 T2313C078 双头螺柱 8.8-A3L STUD 3 2011-11_

2 GBT6170-M10 螺母M10 NUT M10 3 2011-11_
4 T73701009 起动马达 STARTING MOTOR 1 2011-11_

62
TD824-1F161F23K拖拉机

63
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-11 10.11-风扇驱动装置 FAN DRIVE FBH00001

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T4113H058 风扇驱动壳 FAN DRIVING HOUSING 1 2011-11_

2 T2314J014 螺栓 BOLT 4 2011-11_
3 T63910002 皮带轮 BELT WHEEL 1 2011-11_
4 T64401006A 皮带 BELT 1 2011-11_
5 T64406007 风扇叶片 FAN BLADE 1 2011-11_

6 T3748W232 风扇隔圈 FAN RING 1 2011-11_

7 T2314K166 螺栓 BOLT 4 2011-11_

64
TD824-1F161F23K拖拉机

65
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-12 10.12-润滑油底壳-12 LUBRICATING OIL SUMP

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3627P024 桥架 AXLE FRAME 1 2011-11_

10 T2314K213 螺栓 BOLT 2 2011-11_
10 T2314K213 螺栓 BOLT 2 2011-11_
11 GBT5783-M16X45 螺栓 BOLT 4 2011-11_
12 T36832137A 机油管垫 LUB.OIL PIPE JOINT 1 2011-11_

13 T3575A046 吸油管 OIL SUCTION PIPE 1 2011-11_

14 T2314H007 螺栓 BOLT 2 2011-11_
15 T3821D012 支架 SUPPOT BRACKET 1 2011-11_
16 T2314H002 螺栓 BOLT 1 2011-11_
17 T0920484 垫圈 WASHER 1 2011-11_

17 T0920484 垫圈 WASHER 1 2011-11_

18 T3661V002 板 PLATE 1 2011-11_
19 T3661C002 卡子 CLIP 1 2011-11_
2 T2311D039 螺栓 BOLT 2 2011-11_
20 T2314F002 螺栓 BOLT 1 2011-11_

21 T2314F004 螺栓 BOLT 1 2011-11_

21 T2314F004 螺栓 BOLT 1 2011-11_
22 T2318A602 螺母 NUT 2 2011-11_
23 T32186405A 油底堵 OIL SUMP PLUG 2 2011-11_
24 T2415715 O 型圈 O-RING 2 2011-11_

25 T3577A125 油尺管 OIL DIPSTICK PIPE 1 2011-11_

27 T3178C076 油尺 OIL DISTICK 1 2011-11_
28 T33812116 橄榄体 OLIVE 1 2011-11_
29 T2431A016 堵 PLUG 1 2011-11_
3 T63802001A 油底壳 OIL SUMP 1 2011-11_

66
TD824-1F161F23K拖拉机

67
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-12 10.12-润滑油底壳-12(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

4 T36815736B 垫 WASHER 1 2011-11_

5 T2314H055A 螺栓 BOLT 2 2011-11_
5 T2314H055A 螺栓 BOLT 2 2011-11_
6 T2314H023A 螺栓 BOLT 4 2011-11_
7 T2314H023A 螺栓 BOLT 2 2011-11_

8 T2314H015A 螺栓 BOLT 10 2011-11_

9 T2314H012A 螺栓 BOLT 2 2011-11_

68
TD824-1F161F23K拖拉机

69
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-13 10.13-加油口盖板 FILLER COVER PLATE

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T0650586 螺堵 SCREW PLUG 1 2011-11_

1 T0650586 螺堵 SCREW PLUG 1 2011-11_
11 GBT1235-D38X3.1 O形圈 O-RING 1 2011-11_
2 T3617A001 板 PLATE 1 2011-11_
3 T3683H006A 垫 WASHER 1 2011-11_

4 T2314H003 螺栓 BOLT 1 2011-11_

5 T74001201 加油口 FILLING CAP 1 2011-11_
6 T74001003 加油口盖 COVER 1 2011-11_
7 T3683H006A 垫 WASHER 1 2011-11_
8 T2314H010 螺栓 BOLT 1 2011-11_

9 T2314H007 螺栓 BOLT 1 2011-11_

70
TD824-1F161F23K拖拉机

71
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-14 10.14-气缸盖罩 CYLINDER COVER

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T4142X046G 缸盖罩总成 CYLINDER COVER BONNET ASSEMBLY 1 2011-11_

10 T3573A006B 支架 SUPPOT BRACKET 1 2011-11_
2 T3681A021A 缸盖罩垫 CYL. HEAD COVER JOINT 1 2011-11_
3 T3274A003 螺母 NUT 3 2011-11_
4 T0920009 垫圈 WASHER 3 2011-11_

5 T33817135 密封圈 SEAL RING 3 2011-11_

6 T3687A507 防尘条 SEAL 1 2011-11_
7 T33881108E 呼吸管 BREATH PIPE 1 2011-11_
8 T4133J001 呼吸器总成 1 2011-11_
9 T0180066B 卡子 CLIP 1 2011-11_

9 T0180066A 卡子 CLIP 1 2011-11_

9 T0180066B 卡子 CLIP 1 2011-11_

72
TD824-1F161F23K拖拉机

73
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-15 10.15-机油滤清器及机油冷却器 LUBRICATING OIL FILTER & OIL COOLER

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T64101001 机油滤清器 OIL FILTER 1 2011-11_

1.1 T74105021 机油滤清器滤芯 OIL FILTER ELEMENT 1 2011-11_
10 T34821121 弯胶管 BENDING HOSE 3 2011-11_
11 T2481877A 卡箍 CLAMP HOOP 8 2011-11_
12 T74202031 油冷器回水管 OIL COOLER WATER RETURN PIPE 1 2011-11_

13 T74202003 接头 CONNECTING JOINT 1 2011-11_

14 T74202032 连接管 CONNECTING HOSE 1 2011-11_
15 T2314H001 螺栓 BOLT 1 2011-11_
16 T2318A603 螺母 NUT 1 2011-11_
2 T3773T101A 垫板 PAD BOARD 1 2011-11_

21 T2314J010 螺栓 BOLT 2 2011-11_

22 T2314J019 螺栓 BOLT 2 2011-11_
3 T3686T006A 垫 WASHER 2 2011-11_
4 T33554128A 接头 CONNECTING JOINT 1 2011-11_
5 T3773P312A 机滤器滤座 HEAD、LUB. OIL 1 2011-11_

6 T74202012 油冷器(16片) OIL COOLING 1 2011-11_

7 T4126E068G 油冷器进水管 PIPE、 WATER INLET 1 2011-11_
8 T3385H001 连接胶管 CONNECTING RUBBER PIPE 1 2011-11_
9 T64202014 油冷器接头 CONNECTION 1 2011-11_

74
TD824-1F161F23K拖拉机

75
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-17 10.17-水泵及节温器-17 WATER PUMP & THERMOSTAT

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3685R005A 垫 WASHER 1 2011-11_

10 T3746X055 叶轮 IMPELLER 1 2011-11_
11 T3755E001 盖板 COVER PLATE 1 2011-11_
12 T3117A032 齿轮 GEAR 1 2011-11_
13 T2415H494 O 型圈 O-RING 1 2011-11_

14 T2314H015 螺栓 BOLT 1 2011-11_

15 T2314N043 螺栓 BOLT 3 2011-11_
16 T2314H006 螺栓 BOLT 1 2011-11_
17 T2314H006 螺栓 BOLT 1 2011-11_
18 T74405005 节温器 THERMOSTAT 2 2011-11_

19 T3685F005A 节温器壳体垫 RIND JOINT 1 2011-11_

19 T3685F005A 垫 WASHER 1 2011-11_
2 T3623K007 盖板 COVER PLATE 1 2011-11_
20 T3771K121E 节温器壳 THERMOSTAT HOUSING 1 2011-11_
21 T62204004 暖风放水开关 SWITCH 1 2011-11_

22 T2314J013 螺栓 BOLT 2 2011-11_

23 T2314H015 螺栓 BOLT 1 2011-11_
24 T2314H008 螺栓 BOLT 2 2011-11_
25 T3764E061 接头 CONNECTING JOINT 1 2011-11_
25 T3764E061 接头 CONNECTING JOINT 1 2011-11_

26 T2431154 堵 PLUG 1 2011-11_

27 T3683N004A 垫 WASHER 1 2011-11_
28 T2314H004 螺栓 BOLT 2 2011-11_
29 T33854114 胶管 RUBBER HOSE 1 2011-11_
3 T2314J002 螺栓 BOLT 2 2011-11_

76
TD824-1F161F23K拖拉机

77
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-17 10.17-水泵及节温器-17(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

30 T0180067B 卡箍 CLAMP HOOP 2 2011-11_

30 T0180067A 卡箍 CLAMP HOOP 2 2011-11_
31 T2314H002 螺栓 BOLT 2 2011-11_
32 T2314H003 螺栓 BOLT 1 2011-11_
33 T2431154 堵 PLUG 1 2011-11_

4 T4131E018 水泵 WATER PUMP 1 2011-11_

5 T2538624 轴 SHAFT 1 2011-11_
6 T2415B155 O 型圈 O-RING 1 2011-11_
6 T2415B155 O 型圈 O-RING 1 2011-11_
7 T3771D035 水泵泵体 1 2011-11_

8 T2418M006 密封圈 SEAL RING 1 2011-11_

9 T2418F405 油封 OIL SEAL 1 2011-11_

78
TD824-1F161F23K拖拉机

79
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-18 10.18-水出口及入口-18 WATER OUTLET & INLET

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3771K043 出水口 Water outlet 1 2011-11_

2 T3684A004A 垫 WASHER 1 2011-11_
3 T2314H010 螺栓 BOLT 1 2011-11_
4 T2314H008 螺栓 BOLT 1 2011-11_

80
TD824-1F161F23K拖拉机

81
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-19 10.19-交流发电机及发电机 ALTERNATOR & GENERATOR

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 T64505017 碳刷 CARBON BRUSH 1 2011-11_

0 T74501036-1 调节器 ADJUSTER 1 2011-11_
0 T64503054 皮带轮 BELT WHEEL 1 2011-11_
1 T2314H013 螺栓 BOLT 2 2011-11_
10 T2131A010 垫圈10 WASHER 10 1 2011-11_

11 T2131A010 垫圈10 WASHER 10 1 2011-11_

12 T74502206B 支架 SUPPOT BRACKET 1 2011-11_
13 T3827H025B 发电机支架 GENERATOR BRACKET 1 2011-11_
14 T2314J003 螺栓 BOLT 1 2011-11_
15 T2314H002 螺栓 BOLT 4 2011-11_

16 T3753V016 支架 SUPPOT BRACKET 1 2011-11_

17 T2314H018 螺栓 BOLT 1 2011-11_
17 T2314H018 螺栓 BOLT 1 2011-11_
18 T2314H008 螺栓 BOLT 1 2011-11_
19 T3753V014A 调节杆 ADJUSTING ROD 1 2011-11_

2 T74501036 发电机 GENERATOR 1 2011-11_

20 T64502110 隔圈 1 2011-11_
21 T2314J004 螺栓 BOLT 1 2011-11_
3 T2314H007 螺栓 BOLT 1 2011-11_
4 T2314H008 螺栓 BOLT 1 2011-11_

5 T0920497 垫圈 WASHER 3 2011-11_

6 GBT6170-M8 螺母M8 NUT M8 2 2011-11_
8 T2314J006 螺栓 BOLT 1 2011-11_
9 T2318A634 螺母 NUT 1 2011-11_

82
TD824-1F161F23K拖拉机

83
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-2 10.2-正时齿轮及凸轮轴 TIMING GEAR& CAMSHAFT

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T0500012 键 KEY 1 2011-11_

12 T33123125 垫圈 WASHER 1 2011-11_
13 T2722A206 卡簧 CIRCLIP 1 2011-11_
13 T2722A206 卡簧 CIRCLIP 1 2011-11_
14 T31415364 凸轮轴 CAMSHAFT 1 2011-11_

15 T33153121 止推板 PLATE;THRUST 1 2011-11_

16 T2116053 销子 PIN 1 2011-11_
17 T0500012 键 KEY 1 2011-11_
18 T3117L023 齿轮 GEAR 1 2011-11_
19 T2314J606 螺栓 BOLT 1 2011-11_

2 T3117C061 齿轮 GEAR 1 2011-11_

20 T3321A003 垫圈 WASHER 1 2011-11_
20 T3321A003 垫圈 WASHER 1 2011-11_
21 T3716C133A 正时齿轮室 TIMING CASE 1 2011-11_
22 T0650586 螺堵 SCREW PLUG 1 2011-11_

22 T0650586 螺堵 SCREW PLUG 1 2011-11_

23 T3681P009 垫 WASHER 1 2011-11_
24 T2314H003 螺栓 BOLT 8 2011-11_
25 T2314H004 螺栓 BOLT 4 2011-11_
26 T3681P034 正时室盖垫 FRONT COVER JOINT 1 2011-11_

27 T3716M091B 前盖 FRONT COVER 1 2011-11_

28 T2418F436 油封 OIL SEAL 1 2011-11_
29 T2314H005 螺栓 BOLT 9 2011-11_
3 T33426161 轮毂 HUB 1 2011-11_
30 T2314H004 螺栓 BOLT 1 2011-11_

84
TD824-1F161F23K拖拉机

85
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-2 10.2-正时齿轮及凸轮轴(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

31 T2314H004 螺栓 BOLT 3 2011-11_

32 T2314H013 螺栓 BOLT 6 2011-11_
33 T62204001 检查盖 INSPECTION COVER 1 2011-11_
33 T62204001 检查盖 INSPECTION COVER 1 2011-11_
34 T62204002 垫 WASHER 1 2011-11_

35 T2314F006 螺栓 BOLT 4 2011-11_

4 T4111A013 齿轮 GEAR 1 2011-11_
7 T3241H009 固定板 FIXED PLATE 1 2011-11_
8 T2314J010 螺栓 BOLT 3 2011-11_
9 T4111A021 齿轮 GEAR 1 2011-11_

86
TD824-1F161F23K拖拉机

87
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-20.1 10.20.1-空气压缩机-20.1 AIR COMPRESSOR

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3272X021 轮毂 HUB 1 2011-11_

2 T2415H213 O型圈 O-RING 1 2011-11_
3 T3117C161 齿轮 GEAR 1 2011-11_
4 T2551A289 轴承 BEARING 1 2011-11_
5 T3241H011 固定板 FIXED PLATE 1 2011-11_

6 T2314H002 螺栓 BOLT 3 2011-11_

7 T3753R241 支架 SUPPOT BRACKET 1 2011-11_
8 T2311D081 螺栓 BOLT 3 2011-11_
9 T2311D560 螺栓 BOLT 4 2011-11_

88
TD824-1F161F23K拖拉机

89
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-20.2 10.20.2-空气压缩机-20.2 AIR COMPRESSOR

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T2415H461 O型圈 O-RING 1 2011-11_

2 T2313H321 双头螺栓 STUD 1 2011-11_
3 T3254T001 双头螺柱 8.8-A3L STUD 1 2011-11_
4 T2318A605 螺母 NUT 3 2011-11_

90
TD824-1F161F23K拖拉机

91
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-21 10.21齿轮驱动/转向助力选用 GEAR DRIVE AUXILIARY DRIVE OPTION

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T4113H068A 驱动总成 DRIVING ASSEMBLY 1 2011-11_

1 T4113H068A 驱动总成 DRIVING ASSEMBLY 1 2011-11_
10 T2318A605 螺母 NUT 3 2011-11_
2 T3751K071A 驱动块 DRVING PLATE 1 2011-11_
4 T2721A537 卡簧 CIRCLIP 1 2011-11_

5 T3117C116A 齿轮 GEAR 1 2011-11_

6 GBT276-106 深沟球轴承 BEARING 1 2011-11_
7 T2415H461 O型圈 O-RING 1 2011-11_
8 T2313H321 双头螺栓 STUD 1 2011-11_
9 T3254T001 双头螺柱 8.8-A3L STUD 1 2011-11_

92
TD824-1F161F23K拖拉机

93
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-22.1 10.22.1-进排气系统-22.1 MANIFOLDS & EXHAUST SYSTEM

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3777E221B 进气歧管 INTAKE MANIFOLD 1 2011-11_

10 T3766P052C 进气弯管 AIR INLET SYPHON 1 2011-11_
11 T3684N009 垫 WASHER 1 2011-11_
12 T2314H004 螺栓 BOLT 4 2011-11_
13 T3383E008 胶管 RUBBER HOSE 1 2011-11_

14 T0180070A 环箍 Clip 2 2011-11_

14 T0180070B 喉箍 HOOP 2 2011-11_
2 T3688C024 垫 WASHER 1 2011-11_
3 T2314J004 螺栓 BOLT 4 2011-11_
4 T2314J011 螺栓 BOLT 1 2011-11_

5 T2314J048 螺栓 BOLT 1 2011-11_

6 T73306108 油管 PIPE 1 2011-11_
7 T33225412 螺母 NUT 1 2011-11_
8 T33811112 橄榄体 OLIVE 1 2011-11_
9 T2666108A 火焰预热塞 FLAME WARM-UP PLUG 1 2011-11_

94
TD824-1F161F23K拖拉机

95
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-22.2 10.22.2-进排气系统-22.2 MANIFOLDS & EXHAUST SYSTEM

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T64801019 增压器 TURBOCHARGER 1 2011-11_

10 T3683D008A 垫 WASHER 1 2011-11_
11 T3571N007 油管 PIPE 1 2011-11_
12 T2314H003 螺栓 BOLT 2 2011-11_
13 T3383A006 胶管 RUBBER HOSE 1 2011-11_

14 T2481877A 卡箍 CLAMP HOOP 1 2011-11_

15 T3571N008 油管 PIPE 1 2011-11_
16 T36832144A 垫 WASHER 1 2011-11_
17 T2314H003 螺栓 BOLT 2 2011-11_
18 T0201502 接头 CONNECTING JOINT 1 2011-11_

19 TL311KF01 垫圈 WASHER 1 2011-11_

2 TL681VF03 垫 WASHER 1 2011-11_
20 T4123T016B 油管 PIPE 1 2011-11_
21 T33555138 接头 CONNECTING JOINT 1 2011-11_
22 T2318A634 螺母 NUT 1 2011-11_

23 T2131A010 垫圈10 WASHER 10 1 2011-11_

25 T64703009 密封垫片 SEAL WASHER 1 2011-11_
26 GBT6170-M10 螺母M10 NUT M10 3 2011-11_
28 T2313C078 双头螺柱 8.8-A3L STUD 3 2011-11_
3 TL254HF03A 丝对 STUD 4 2011-11_

4 T2318A633 螺母 NUT 4 2011-11_

5 T2313M387 丝对 STUD 3 2011-11_
5 T2313M387 丝对 STUD 3 2011-11_
6 T2313M388 丝对 STUD 1 2011-11_
7 T2318A634 螺母 NUT 4 2011-11_

96
TD824-1F161F23K拖拉机

97
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-22.2 10.22.2-进排气系统-22.2(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

8 T3681V505 排气歧管垫 EXHAUST MANIFOLD JOINT 2 2011-11_

9 T3778H201A 排气管 EXHAUST PIPE 1 2011-11_

98
TD824-1F161F23K拖拉机

99
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-23 10.23-燃油滤清器及油管-23 FUEL FILTER AND PIPE

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T75004250 燃油滤清器 FUEL FILTER 1 2011-11_

1.1 T75004251 燃油滤清器滤芯 FUEL FILTER STRAINER CORE 1 2011-11_
10 T75004276 支架 SUPPOT BRACKET 1 2011-11_
11 T2314J002 螺栓 BOLT 2 2011-11_
12 T73306109 回油管 OIL RETURN PIPE 1 2011-11_

12 T73217018 油管 PIPE 1 2011-11_

13 T33225412 螺母 NUT 2 2011-11_
14 T33811112 橄榄体 OLIVE 2 2011-11_
15 T73306107 油管 PIPE 1 2011-11_
16 T33811114 橄榄体 OLIVE 1 2011-11_

17 T73306106 回油管 OIL RETURN PIPE 1 2011-11_

18 T73306112 油管 PIPE 1 2011-11_
18 T73306112 油管 PIPE 1 2011-11_
19 T0650204 堵 PLUG 1 2011-11_
2 T0095344A 过油螺栓 BOLT 1 2011-11_

20 T73274309 密封垫圈 SEAL RING 1 2011-11_

3 T73217019 接头 CONNECTING JOINT 1 2011-11_
4 T73208144 垫圈 WASHER 2 2011-11_
5 T0576113 螺母 NUT 1 2011-11_
6 T0566004 橄榄体 OLIVE 1 2011-11_

7 T65005001A 油管 PIPE 1 2011-11_

8 T2314J005 螺栓 BOLT 2 2011-11_
9 T2318A604 螺母 NUT 2 2011-11_

100
 TD824-1F161F23K拖拉机

101
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-24 10.24-输油泵和盖板-24 LIFT PUMP AND BLANKING PLATES

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T63207003A 盖板 COVER PLATE 1 2011-11_

1 T63207003A 盖板 COVER PLATE 1 2011-11_
2 T36856104A 输油泵垫 OIL CONVEYING PUMP GASKET 1 2011-11_
5 GBT5783-M8X20 螺栓 BOLT 4 2011-11_
5 GBT5783-M8X20 螺栓 BOLT 4 2011-11_

102
 TD824-1F161F23K拖拉机

103
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-25 10.25-发动机总成-25 ENGINE ASSEMBLY-25

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T74502205A 吊耳 BRACKET,LIFTING 1 2012-08_

2 T2314J003 螺栓 BOLT 3 2012-08_
3 T3654W003 后吊耳 REAR LIFTING RING 1 2012-08_

104
 TD824-1F161F23K拖拉机

105
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-25 10.25-发动机提升 ENGINE LIFTING

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3654W003 后吊耳 REAR LIFTING RING 1 2011-11_

2 T2314J003 螺栓 BOLT 2 2011-11_
3 T74502205A 吊耳 BRACKET,LIFTING 1 2011-11_
4 T2314J003 螺栓 BOLT 3 2011-11_

106
 TD824-1F161F23K拖拉机

107
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-26 10.26-发动机总成-26 ENGINE ASSEMBLY-26

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T2313M101 双头螺柱 8.8-A3L STUD 8 2012-08_

2 T2318A605 螺母 NUT 8 2012-08_
3 Q150B1640Q 螺栓 BOLT 4 2012-08_
4 Q40316 垫圈 WASHER 4 2012-08_
5 T66003001 左前支架 LEFT FRONT BRACKET 1 2012-08_

5 T66003001 左前支架 LEFT FRONT BRACKET 1 2012-08_

6 T66003002 右前支架 RIGHT FRONT BRACKET 1 2012-08_

108
 TD824-1F161F23K拖拉机

109
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-26 10.26支撑 MOUNTINGS

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T2313M101 双头螺柱 8.8-A3L STUD 8 2011-11_

2 T2318A605 螺母 NUT 8 2011-11_
3 GBT5783-M16X40 六角头螺栓 BOLT 4 2011-11_
5 T66003001 左前支架 LEFT FRONT BRACKET 1 2011-11_
5 T66003001 左前支架 LEFT FRONT BRACKET 1 2011-11_

6 T66003002 右前支架 RIGHT FRONT BRACKET 1 2011-11_

110
 TD824-1F161F23K拖拉机

111
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-27 10.27-发动机总成-27 ENGINE ASSEMBLY-27

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T62204003 放水开关 DRAIN SWITCH 1 2012-08_

2 T0180063A 卡箍 CLAMP HOOP 1 2012-08_
3 T64403007 放水管 DRAIN PIPE 1 2012-08_
4 T64403008 支架 SUPPOT BRACKET 1 2012-08_
5 T32161114 堵 PLUG 1 2012-08_

112
 TD824-1F161F23K拖拉机

113
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-27 10.27-放水阀 DRAIN VALVE

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T62204003 放水开关 DRAIN SWITCH 1 2011-11_

2 T64403007 放水管 DRAIN PIPE 1 2011-11_
3 T64403008 支架 SUPPOT BRACKET 1 2011-11_
4 T0180063A 卡箍 CLAMP HOOP 1 2011-11_
5 T32161114 堵 PLUG 1 2011-11_

6 T0650594 堵 PLUG 1 2011-11_

114
 TD824-1F161F23K拖拉机

115
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-28 10.28-发动机总成-28 ENGINE ASSEMBLY-28

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TU5LT0178 顶部垫片 TOP WASHER 1 2012-08_

116
 TD824-1F161F23K拖拉机

117
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-28 10.28-垫及垫片（顶部维修组件） JOINTS & GASKETS-TOP SERVICE KIT

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TU5LT0178 顶部垫片 TOP WASHER 1 2011-11_

10 T3688C024 垫 WASHER 1 2011-11_
11 T3684N009 垫 WASHER 1 2011-11_
12 T3684A004A 垫 WASHER 1 2011-11_
13 T3683D008A 垫 WASHER 1 2011-11_

14 T36832144A 垫 WASHER 1 2011-11_

15 T3683N004A 垫 WASHER 1 2011-11_
2 T3681E033 气缸盖垫 CYLINDER COVER GASKET 1 2011-11_
3 T3681A021A 缸盖罩垫 CYL. HEAD COVER JOINT 1 2011-11_
4 T3685R005A 垫 WASHER 1 2011-11_

5 T3685F005A 节温器壳体垫 RIND JOINT 1 2011-11_

5 T3685F005A 垫 WASHER 1 2011-11_
6 TL681VF03 垫 WASHER 1 2011-11_
7 T3681V505 排气歧管垫 EXHAUST MANIFOLD JOINT 2 2011-11_
8 T64703009 密封垫片 SEAL WASHER 1 2011-11_

9 T3688C018 密封垫片 SEAL WASHER 1 2011-11_

118
 TD824-1F161F23K拖拉机

119
 TD824-1F161F23K拖拉机

1004C-P4TRT82N02-29 10.29-发动机总成-29 ENGINE ASSEMBLY-29

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TU5LB0051 底部垫片 BOTTOM WASHER 1 2012-08_

120
 TD824-1F161F23K拖拉机

121
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-29 10.29-垫及垫片（底部维修组件） JOINTS & GASKETS-BOTTOM SERVICE KIT

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TU5LB0051 底部垫片 BOTTOM WASHER 1 2011-11_

2 T36815736B 垫 WASHER 1 2011-11_
3 T3681P009 垫 WASHER 1 2011-11_
4 T3681P034 正时室盖垫 FRONT COVER JOINT 1 2011-11_
5 T62204002 垫 WASHER 1 2011-11_

6 T3686T006A 垫 WASHER 1 2011-11_

7 T33828118A 燃油泵垫 FUEL PUMP GASKET 1 2011-11_
8 T36856104A 输油泵垫 OIL CONVEYING PUMP GASKET 1 2011-11_
9 T36832137A 机油管垫 LUB.OIL PIPE JOINT 1 2011-11_

122
 TD824-1F161F23K拖拉机

123
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-3 10.3-曲轴活塞及连杆-3 CRANKSHAFT PISTONS & CONNECTING RODS

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T31315681 曲轴 CRANK SHAFT 1 2011-11_

10 T2721332 卡簧 CIRCLIP 8 2011-11_
11 T4115C211 连杆 CONNECTING ROD 4 2011-11_
11 T4115C211 连杆总成 CONNECTING ROD ASSEMBLY 4 2011-11_
14 T31132011 轴瓦 BEARING 4 2011-11_

2 T81558 主轴瓦 MAIN BEARING 1 2011-11_

3 TZZ90001 止推片总成 THRUST SHIM ASSEMBLY 1 2011-11_
4 T3135J186A 活塞 PISTON 4 2011-11_
5 T4181A026 活塞环总成 PISTON RING ASSEMBLY 4 2011-11_
9 T3313T005 活塞销 PISTON PIN 4 2011-11_

124
 TD824-1F161F23K拖拉机

125
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-4 10.4-气缸盖 CYLINDER COVER

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3681E033 气缸盖垫 CYLINDER COVER GASKET 1 2011-11_

10 T0650710 碗堵 COREHOLE PLUG 1 2011-11_
11 T32417121 出沙孔堵 PLUG 4 2011-11_
11 T32417121 出沙孔堵 PLUG 4 2011-11_
12 T3343F041 气门导管 VALVE STEM GUIDE 4 2011-11_

13 T3343J021 气门导管 VALVE STEM GUIDE 4 2011-11_

14 T2114A046 定位销 THIMBLE 2 2011-11_
15 T32166219 螺栓 BOLT 8 2011-11_
16 T32166221 螺栓 BOLT 12 2011-11_
17 T32166222 螺栓 BOLT 2 2011-11_

18 T3142L072 进气门 AIR INLET VALVE 4 2011-11_

19 T33817117 密封套 SEAL SLEEVE 4 2011-11_
2 TZZ80221 缸盖（总成） CYLINDER COVER ASSEMBLY 1 2011-11_
20 T31745122 气门弹簧 VALVE SPRING 4 2011-11_
21 T31744133 气门弹簧 VALVE SPRING 4 2011-11_

22 T33415118 垫圈 WASHER 4 2011-11_

23 T33424107 气门座 VALVE SEAT 4 2011-11_
24 T33173108 气门锁夹 LOCK 8 2011-11_
25 T3142A051 排气门 EXHAUST VALVE 4 2011-11_
26 T33817117 密封套 SEAL SLEEVE 4 2011-11_

27 T31745122 气门弹簧 VALVE SPRING 4 2011-11_

28 T31744133 气门弹簧 VALVE SPRING 4 2011-11_
29 T33415118 垫圈 WASHER 4 2011-11_
3 T3712H074 气缸盖 CYLINDER COVER 1 2011-11_
30 T33424107 气门座 VALVE SEAT 4 2011-11_

126
 TD824-1F161F23K拖拉机

127
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-4 10.4-气缸盖(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

31 T33173108 气门锁夹 LOCK 8 2011-11_

4 T3342E003 进气阀座 INLET VALVE SEAT 4 2011-11_
5 T3314A122 排气门座 INSERT-VALVE SEAT(OUTLET) 4 2011-11_
6 T0650586 螺堵 SCREW PLUG 4 2011-11_
6 T0650586 螺堵 SCREW PLUG 4 2011-11_

7 T0650203 堵 PLUG 1 2011-11_

8 T2431154 堵 PLUG 2 2011-11_
9 T2411157 垫圈 WASHER 1 2011-11_

128
 TD824-1F161F23K拖拉机

129
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-5 10.5-摇臂轴 ROCKER SHAFT

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T2313H331 双头螺柱 8.8-A3L STUD 3 2011-11_

10 T4115R305 右摇臂 RIGHT ARM SHAFT 4 2011-11_
13 T32114145 调节螺钉 ADJUSTING SCREW 8 2011-11_
14 T0576052 螺母 NUT 8 2011-11_
15 T31744123 弹簧 SPRING 2 2011-11_

16 T31743108 弹簧 SPRING 2 2011-11_

17 T33117434 垫圈 WASHER 2 2011-11_
18 T0170151 卡簧 CIRCLIP 2 2011-11_
19 T3142U031 挺柱 TAPPET 8 2011-11_
19 T3142U031 挺柱 TAPPET 8 2011-11_

2 T2318A605 螺母 NUT 3 2011-11_

20 T31434307 推杆 PUSH ROD 8 2011-11_
21 T3775E012 接头 CONNECTING JOINT 1 2011-11_
22 T2233022 螺栓 BOLT 1 2011-11_
23 T33811113 橄榄体 OLIVE 1 2011-11_

24 T3311K015 垫片 WASHER 2 2011-11_

3 T2314J607 螺栓 BOLT 1 2011-11_
4 T3818X901 支架 SUPPOT BRACKET 4 2011-11_
5 T31411124 摇臂轴 ROCKER SHAFT 1 2011-11_
6 T0650507 堵 PLUG 2 2011-11_

7 T4115R306 左摇臂 LEFT ROCKER 4 2011-11_

130
 TD824-1F161F23K拖拉机

131
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-6 10.6-润滑油泵-6 LUBRICATING OIL PUMP

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T4132F056C 机油泵 OIL PUMP 1 2011-11_

2 T2314H005 螺栓 BOLT 3 2011-11_
3 T4138A049 限压阀总成 PRESSURE LIMITING VALVE ASSEMBLY 1 2011-11_
4 T2314J011 螺栓 BOLT 1 2011-11_
5 T3748C011 发兰 FLANGE 1 2011-11_

6 T2314H004 螺栓 BOLT 2 2011-11_

7 T2415H201 O 型圈 O-RING 2 2011-11_
8 T3343F012 油管 PIPE 1 2011-11_

132
 TD824-1F161F23K拖拉机

133
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-7.1 10.7.1-燃油喷射系统-7.1 FUEL INJECTION EQUIPMENT

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3558X043 油管 PIPE 1 2011-11_

10 T2314H006 螺栓 BOLT 8 2011-11_
11 T33813131 防尘套 DUST COVER 4 2011-11_
12 T0921173 垫圈 WASHER 4 2011-11_
12 T0921173 垫圈 WASHER 4 2011-11_

2 T3218R005 过油螺栓 BOLT 3 2011-11_

3 T3355V002 过油螺栓 BOLT 1 2011-11_
4 T2411101 垫圈 WASHER 8 2011-11_
4 T2411101 垫圈 WASHER 8 2011-11_
5 T63301004 喷油器总成 INJEKTOR ASSEMBLY 4 2011-11_

5 T63301009 喷油器总成 INJEKTOR ASSEMBLY 4 2011-11_

5 T73302131 喷油器总成 INJEKTOR ASSEMBLY 4 2011-11_
7 T2645F615 喷油嘴 OIL INJECTOR NOZZLE 4 2011-11_
7 T73302131-1 喷油嘴 OIL INJECTOR NOZZLE 4 2011-11_
8 T3662K002 压板 PRESSURE PLATE 4 2011-11_

9 T33813129 垫圈 WASHER 4 2011-11_

134
 TD824-1F161F23K拖拉机

135
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-7.2 10.7.2-燃油喷射系统-7.2 FUEL INJECTION EQUIPMENT

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 T73208141-2 二缸油管 2ND CYLINDER OIL PIPE 1 2011-11_

0 T73208141-GJ4 管夹（四孔） CLIP （FOUR HOLE） 1 2011-11_
0 T73208141-1 一缸油管 I CYLINDER PIPE 1 2011-11_
0 T73208141-GJ3 管夹（3孔） CLIP （THREE HOLE） 1 2011-11_
0 T73208141-GJ2 管夹（两孔） CLIP （TWO HOLE） 1 2011-11_

0 T73208141-GJ2 管夹（两孔） CLIP （TWO HOLE） 1 2011-11_

0 T73208141-2 二缸油管 2ND CYLINDER OIL PIPE 1 2011-11_
0 T73208141-3 3缸油管 THREE CYLINDER PIPE 1 2011-11_
0 T73208141-4 四缸油管 4 CYLINDER OIL PIPE 1 2011-11_
0 T73208141-3 3缸油管 THREE CYLINDER PIPE 1 2011-11_

1 T3117L113G 直列泵齿轮 STRAIGHT PUMP GEAR 1 2011-11_

10 T73208301 喷油泵支架 SUPPORT AS. 1 2011-11_
10 T73208301 支架 SUPPOT BRACKET 1 2011-11_
11 T73201638 支架 SUPPOT BRACKET 1 2011-11_
11 T73201652 支架 SUPPOT BRACKET 1 2011-11_

12 T63274204 支撑板 SUPPORTING BOARD 1 2011-11_

13 T63274205 双头螺栓 STUD 1 2011-11_
13 T63274205 双头螺栓 STUD 1 2011-11_
14 GBT97.1-D10 平垫圈 WASHER 2 2011-11_
16 GBT6170-M10 螺母M10 NUT M10 2 2011-11_

17 GBT5783-M10X25 螺栓 BOLT 2 2011-11_

18 GBT97.1-D10 平垫圈 WASHER 4 2011-11_
2 T73208354 喷油泵 OIL INJECTION PUMP 1 2011-11_
2 T63211894A 喷油泵 OIL INJECTION PUMP 1 2011-11_
20 GBT5783-M8X30 六角头螺栓 BOLT 1 2011-11_

136
 TD824-1F161F23K拖拉机

137
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-7.2 10.7.2-燃油喷射系统-7.2(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

21 GBT5783-M8X35 六角头螺栓 BOLT 1 2011-11_

22 GBT6170-M8 螺母M8 NUT M8 2 2011-11_
23 GBT97.1-D8 平垫圈 WASHER 4 2011-11_
25 T4126E081C 进气补偿管 PIPE 1 2011-11_
26 T33225412 螺母 NUT 1 2011-11_

27 T33811112 橄榄体 OLIVE 1 2011-11_

28 T0201047 弯管 BENDING PIPE 1 2011-11_
28 T0201047 弯管 BENDING PIPE 1 2011-11_
3 T3821D015A 调整板 ADJUSTING BOARD 1 2011-11_
4 T33828108A 垫 WASHER 1 2011-11_

5 T33828118B 垫 WASHER 1 2011-11_

6 Q1201040F3S 双头螺栓 STUD 4 2011-11_
6 Q1201040F3S 双头螺柱 8.8-A3L STUD 4 2011-11_
7 T2318A604 螺母 NUT 4 2011-11_
8 T73208141 高压油管 HIGH PRESSURE OIL HOSE 1 2011-11_

9 T73214101 油管 PIPE 1 2011-11_

138
 TD824-1F161F23K拖拉机

139
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-8 10.8-飞轮板 FLYWHEEL PLATE

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T73631004A 飞轮板 FLYWHEEL PLATE 1 2011-11_

2 T73606004 飞轮板定位套 FLYWHEEL PLATE LOCATING BUSH 2 2011-11_
3 T36843154 密封条 SEAL STRIP 1 2011-11_
4 T73631005 盖板 COVER PLATE 1 2011-11_
5 GBT5783-M6X10 六角头螺栓 BOLT 2 2011-11_

7 T2314J204 螺栓 BOLT 6 2011-11_

8 T0350025 飞轮壳定位销 FLYWHEEL HOUSING DOWEL PIN 2 2011-11_
9 GBT5783-M12X45 六角头螺栓 BOLT 2 2011-11_

140
 TD824-1F161F23K拖拉机

141
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-9 10.9-飞轮及启动齿圈 FLYWHEEL & STARTER RING

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T63640800K1 飞轮部 FLYWHEEL ASSEMBLY 1 2011-11_

2 T63616008 飞轮 FLYWHEEL 1 2011-11_
3 T31162121B 齿圈 GEAR RING 1 2011-11_
4 T2185103 螺栓 BOLT 10 2011-11_
5 T33117127 垫圈 WASHER 10 2011-11_

6 GBT276-6303-2Z 深沟球轴承 BEARING 1 2011-11_

142
 TD824-1F161F23K拖拉机

143
 TD824-1F161F23K拖拉机

TD800.11B 11-空气滤清系总成 11-AIR CLEANER ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M8X25-A2L 螺栓 BOLT 1 2011-11_

10 Q67689 喉箍 HOOP 1 2011-11_
11 FT800A.11.011 支架焊合 BRACKET WELDMENT 1 2011-11_
12 FT800A.11.010-05 空滤器滤芯 AIR FILTER ELEMENT 1 2011-11_
12 FT800A.11.010 空滤器总成 AIR FILTER ASSEMBLY 1 2011-11_

13 GBT5783-M8X20-A2L 螺栓 BOLT 4 2011-11_

2 TD800.11B.1 进气管焊合 AIR INLET PIPE WELDMENT 1 2011-11_
3 GBT97.1-8-A0P 平垫圈 WASHER 3 2011-11_
4 GBT93-8-A0P 垫圈 WASHER 10 2011-11_
5 GBT6170-M8-A2L 螺母 NUT 1 2011-11_

6 GBT5783-M8X16-A2L 螺栓 BOLT 5 2011-11_

7 TD800.11A-01 进气软管1 AIR INLET HOSE 1 1 2011-11_
8 Q67676 环箍 Clip 3 2011-11_
9 TD800.11A-02 进气软管2 AIR INLET HOSE 2 1 2011-11_
9 TD800.11A-02 进气软管2 AIR INLET HOSE 2 1 2011-11_

144
 TD824-1F161F23K拖拉机

145
 TD824-1F161F23K拖拉机

TD800.131 13.1-冷却系总成 13.1-COOLING SYSTEM ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M8X25-8.8-A2L 六角头螺栓 BOLT 12 2008-03_

1 GBT5783-M8X20-8.8-A2L 六角头螺栓 BOLT 12 2012-10_
10 Q67664 B型蜗杆传动式软管环箍 B-TYPE WORM TRANSMISSION HOSE CLAMP 2
11 TD800.131-02 水箱出水胶管 WATER TANK OUTLET RUBBER HOSE 1
12 TD800.131-01a 水箱j进水软管 1 2010-08_

12 TD800.131-01 水箱进水胶管 WATER TANK INLET RUBBER HOSE 1

13 TD800.131-10a 散热器总成 RADIATER ASSEMBLY 1 2010-08_
13 TD800.131-10 散热器总成 RADIATER ASSEMBLY 1
14 GBT93-8-A0P 垫圈 WASHER 12
15 TD800.131-03 右防护板 RIGHT GUARD PLATE 1

15 TD800.131-03 右防护板 RIGHT GUARD PLATE 1

16 TD800.131-07 左防护板 LEFT GUARD PLATE 1
17 TD800.131-05 右安装板2 RIGHT INSTALLATION PLATE 2 1
17 TD1000.131H.3 右安装板焊合 RIGHT FIX WELDMENT 1 2012-10_
18 GBT6170-M8-8-A2L Ⅰ型六角螺母 I-TYPE HEXAGON NUT 8

2 GBT96.1-8-A0P 垫圈 WASHER 20
3 TD1000.131H.2 左安装板焊合 LEFT INSTALLATION PLATE WELDMENT 1 2012-10_
3 TD800.131-09 左安装板1 LEFT INSTALLATION PLATE 1 1
4 TD800.131-12 套管 SLEEVE 2
5 GBT91-2.5X28-A0P 开口销 PIN 2

6 GBT6178-M10-8-A3L 1型六角开槽螺母 NUT (PAGE81) 2

7 FT650.13.116 垫片 WASHER 2
8 TD800.131-11 橡胶垫块 RUBBER PAD BLOCK 4 2011-06_
8 FT650.13.112 橡胶垫块 RUBBER PAD BLOCK 4
9 Q67670 B型蜗杆传动式软管环箍 B-TYPE WORM TRANSMISSION HOSE CLAMP 2

146
 TD824-1F161F23K拖拉机

147
 TD824-1F161F23K拖拉机

TD800.132A 13.2-支架安装总成 13.2-BRACKET INSTALLATION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M10X25-A3L 螺栓 BOLT 6 2011-11_

2 GBT93-10-A0P 标准型弹簧垫圈 WASHER 6 2011-11_
3 GBT97.1-10-AOP 垫圈 WASHER 6 2011-11_
4 TD800.132.2 电瓶安装支架 BATTERY INSTALLATION BRACKET 1 2011-11_
5 TD900.132.1 水箱垫板焊合 RADIATOR BACKING BOARD WELDMENT 1 2011-12_

5 TD800.132A.1 水箱垫板焊合 RADIATOR BACKING BOARD WELDMENT 1

148
 TD824-1F161F23K拖拉机

149
 TD824-1F161F23K拖拉机

TD800.201 20.1-手油门操纵总成 20.1-HAND THROTTLE CONTROL ASSSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TA700.201-01 手油门总成 HANDLE THROTTLE ASSEMBLY 1 2010-06_

1 TD800.201-01 手油门总成 HANDLE THROTTLE ASSEMBLY 1 2010-07_
1 FT800.20L.019 手油门总成 HANDLE THROTTLE ASSEMBLY 1 1998-08_
10 GBT6170-M8-A2L 螺母 NUT 1 2011-11_
2 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 3 2011-11_

3 GBT5781-M6X16-A2L 六角头螺栓 BOLT 3 2011-11_

4 FT700.20.324 手油门盖 HAND THROTTLE COVER 1 2011-11_
5 GBT5780-M10X45-A3L 六角头螺栓 BOLT 1 2011-11_
6 GBT96-10-A0P 垫圈 WASHER 1 2011-11_
7 GBT68-M8X30-A2L 开槽沉头螺钉 SCREW 3 2011-11_

8 FT650.20.133 紧固螺钉 LOCKING SCREW 1 2011-11_

9 GBT97.1-8-A0P 平垫圈 WASHER 1 2011-11_

150
 TD824-1F161F23K拖拉机

151
 TD824-1F161F23K拖拉机

TA700.202 20.2-脚油门总成 20.2-FOOT THRORRLE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 FT65.45.393 油门踏板密封套 THROTTLE PEDAL SEAL SLEEVE 1 2008-11_

1 FT650.20.101 脚踏板 FOOT PEDAL 1 2011-11_
10 GBT93-8-A0P 垫圈 WASHER 2 2011-11_
11 FT650.20.114 手油门摇臂 HAND THROTTLE ROCKER 1 2011-11_
12 FT650.20.011 脚油门摇臂焊合 FOOT THROTTLE ROCKER ARM WELDMENT 1 2011-11_

2 GBT879.1-5X20-A0P 销 PIN 2
3 FT800.20.013 脚踏板摇臂焊合 FOOT PEDAL ROCKER ARM WELDMENT 1 2011-11_
4 FT650.20.107 橡胶塞 RUBBER RING 1 2011-11_
5 GBT5781-M8X45-A2L 六角头螺栓 BOLT 1 2011-11_
6 GBT6172.1-M8-A2L 螺母 NUT 3 2011-11_

7 GBT5781-M8X20-A2L 六角头螺栓 BOLT 2 2011-11_

7 GBT5781-M8X20-A2L 六角头螺栓 BOLT 2 2011-11_
8 FT650.20.108 油门支架 THROTTLE PEDESTAL 1 2011-11_
9 FT650.20.104 扭簧 TORSION SPRING 1 2011-11_

152
 TD824-1F161F23K拖拉机

153
 TD824-1F161F23K拖拉机

TD800.203C 20.3-拉线总成 20.3-PULL WIRE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT750.20.018 熄火拉线总成 EXTINGUISH WIRE ASSEMBLY 1 2011-11_

1 FT650.20.018 熄火拉线总成 EXTINGUISH WIRE ASSEMBLY 1 2006-05_
2 FT800.20.014a 脚油门拉线总成 FOOT THROTTLE WIRE ASSEMBLY 1 2011-11_
3 GBT882-B5X20-A0P 销轴 PIN 1
4 GBT97.1-6-A0P 平垫圈 WASHER 2 2011-11_

5 GBT91-2X12-A0P 开口销 PIN 2 2011-11_

154
 TD824-1F161F23K拖拉机

155
 TD824-1F161F23K拖拉机

FT800.21C.001 21-离合器总成 21-CLUTCH ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 L-03031-0757-04 副离合器从动盘总成 AUXILIARY CLUTCH DRIVEN PLATE ASSEMBLY 1 2011-11_

10 L-02615-0051-02 主分离杆总成 MAIN RELEASE LEVER ASSEMBLY 3 2011-11_
2 L-02103-0733-00 副离合器压盘 AUXILIARY CLUTCH PRESSURE PLATE 1 2011-11_
3 L-04130-0003-01 膜片弹簧 FILM SPRING 1 2011-11_
4 L-02165-0105-01 支承圈 SUPPORT WASHER 1 2011-11_

5 L-00454-0002-00 弹性圆柱销 PIN 1 2011-11_

6 L-02103-0732-10 主离合器压盘 MAIN CLUTCH PRESSURE PLATE 1 2011-11_
7 L-03031-0117-00 主从动盘总成 MAIN DRIVEN PLATE ASSEMBLY 1 2011-11_
8 L-02101-0215-06 离合器壳 CLUTCH HOUSING 1 2011-11_
9 L-02615-0031-02 副分离杆总成 AUXILIARY RELEASE LEVER ASSEMBLY 3 2011-11_

156
 TD824-1F161F23K拖拉机

157
 TD824-1F161F23K拖拉机

FT800A.21C.002-1 21.1-离合器操纵总成-1 CLUTCH CONTROL ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800A.21.043 副离合操纵把手总成 AUXILIARY CLUTCH CONTROL HANDLE 1 2011-11_

1.1 FT800A.43.065 制动联锁杆焊合 ASSEMBLY 1 2011-11_
1.1 FT800A.21.045 按钮总成 BRAKE CONNECTING LOCK ROD WELDMENT 1 2011-11_
1.11 FT800A.21.323 销 BUTTON ASSEMBLY 1 2011-11_
1.12 FT800A.21.337a 副离合拉杆 PIN 1 2011-11_
AUXILIARY CLUTCH PULL ROD
1.13 FT800A.43.310 棘轮 1 2011-11_
1.14 GBT894.1-13 轴用弹性挡圈 RATCHET WHEEL 2 2009-04_
1.15 FT800A.21.321 销轴 SNAP RING 1 2011-11_
1.16 FT800A.21.065 副离合操纵把手固定座合件 PIN 1 2011-11_
1.2 FT800A.21.319 操纵把手套 AUXILIARY CLUTCH CONTROL HANDLE FIXING 1 2011-11_
SEAT UNIT
1.3 FT800.43.180 弹簧 CONTROLLING HANDLE SLEEVE 1 2011-11_
1.4 FT800A.21.315 顶杆 1 2011-11_
1.5 FT800A.21.320 护罩 SPRING 1 2011-11_
1.6 GBT68-M4X10-4.8-A2L 开槽沉头螺钉 TOP ROD 4 2009-04_
1.7 FT800A.21.322 小销轴 BONNET 1 2011-11_
SCREW
1.8 FT800A.21.044 操纵把手总成 SMALL PIN SHAFT 1 2011-11_
1.9 FT800A.21.314 棘爪 1 2011-11_
10 GBT894.1-30 挡圈 CONTROLLING HANDLE ASSEMBLY 1
11 GBT882-B10X30 销轴 PAWL 1 2004-01_
12 GBT848-10-A0P 小垫圈 RETAINER RING 1 2004-01_
PIN
13 GBT91-3.2X20-A0P 开口销 WASHER 1 2004-01_
13 GBT91-3.2X20-A0P 开口销 1 2004-01_
14 GBT848-30-A0P 小垫圈 PIN 1 2004-01_
15 FT800A.21.070 副离合支撑轴焊合 PIN 1 2011-11_
2 GBT5781-M8X30-A2L 六角头螺栓 WASHER 2 2004-01_

158
 TD824-1F161F23K拖拉机

159
 TD824-1F161F23K拖拉机

FT800A.21C.002-1 21.1-离合器操纵总成-1(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

3 GBT93-8-A0P 垫圈 WASHER 4 2004-01_

4 GBT41-M8-5-A2L 六角螺母 HEXAGON NUT 4 2004-01_
5 GBT5781-M8X16-A2L 六角头螺栓 BOLT 2 2004-01_
6 GBT6171-M10X1-A2L 螺母 NUT 1 2004-01_
7 FT800.21.240 拉杆前叉 PULL ROD FRONT FORK 1 2011-11_

8 GBT5781-M10X30-A3L 六角头螺栓 BOLT 4 2004-01_

9 GBT93-10-A0P 标准型弹簧垫圈 WASHER 4 2004-01_

160
 TD824-1F161F23K拖拉机

161
 TD824-1F161F23K拖拉机

FT800A.21C.002-2 21.2-离合器操纵总成-2 CLUTCH CONTROL ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800A.21.062a 副离合转毂合件 AUXILIARY CLUTCH TURN HUB UNIT 1 2011-11_

1 FT800A.21.062a 副离合转毂合件 AUXILIARY CLUTCH TURN HUB UNIT 1 2011-11_
1.1 FT800A.21.338a 副离合转毂 AUXILIARY CLUTCH TURN HUB 1 2011-11_
1.2 FT800A.21.386 转轴衬套 BUSH 1 2010-10_
1.2 FT800A.21.372 副离合转轴衬套 AUXILIARY CLUTCH TURN SHAFT BUSH 1 2004-01_

10 GBT5781-M10X60-A2L 六角头螺栓 BOLT 1 2004-01_

11 FT800A.21.059a 副离合拉杆焊合 AUXILIARY CLUTCH PULL ROD WELDMENT 1 2011-11_
12 FT800.21.028 副离合摇摆轴焊合 AUXILIARY CLUTCH SWING SHAFT WELDMENT 1 2011-11_
13 GBT6171-M10X1-A2L 螺母 NUT 2 2011-11_
14 FT800.21.240 拉杆前叉 PULL ROD FRONT FORK 2 2011-11_

15 FT800.21.204 主离合拨叉 MAIN CLUTCH FORK 1 2011-11_

16 FT800.21.239 紧定螺钉 LOCKING SCREW 2 2011-11_
17 TA800.212B-02 低碳钢丝 LOW CARBON STEEL WIRE 2 2011-11_
18 FT800.21.213 圆柱销 PIN 2 2011-11_
19 FT800.21C.205 主离合分离轴承座 MAIN CLUTCH RELEASE BEARING SEAT 1 2011-11_

2 GBT882-B10X30 销轴 PIN 3 2011-11_

20 FT800.21.203 副离合拨叉 AUXILIARY CLUTCH FORK 1 2011-11_
21 FT800.21.215 副离合回位弹簧 AUXILIARY CLUTCH RETURN SPRING 2 2011-11_
22 FT800.21C.202a 副离合轴承座 AUXILIARY CLUTCH BEARING SEAT 1 2009-04_
23 GBT292-7016AC 角接触球轴承 BEARING 1 2004-01_

24 TA800.212-02 推力轴承99 67 13 THRUST BEARING 1 2011-11_

25 FT800A.21.080 中间杆焊合 MIDDLE ROD WELDMENT 1 2011-10_
25 FT800A.21.071 中间杆焊合 MIDDLE ROD WELDMENT 1 2010-01_
26 FT800A.21.058a 主离合摇臂轴焊合 MAIN CLUTCH ROCKER SHAFT WELDMENT 1 2010-01_
27 FT800A.21.383 回位弹簧 RETURN SPRING 1 2011-11_

162
 TD824-1F161F23K拖拉机

163
 TD824-1F161F23K拖拉机

FT800A.21C.002-2 21.2-离合器操纵总成-2(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

28 FT800A.21.335 叉形接头 FORK JOINT 1 2011-11_

29 GBT6170-M8-A2L 螺母 NUT 2 2011-11_
3 GBT848-10-A0P 小垫圈 WASHER 4 2011-11_
30 FT800.21C.202 副离合轴承座 AUXILIARY CLUTCH BEARING SEAT 1 2004-01_
31 JBT7940.2-45dM10X1 接头式压注油杯 FORCED FILLING OIL CUP、 W/JOINT 1 2011-11_

32 TA820.213-10 分离轴承 BEARING 1 2009-04_

33 FT800.21.209 防尘盖 DUSTPROOF COVER 1 2004-01_
34 FT800.21C.301 副离合分离盘 AUXILIARY CLUTCH RELEASE DISC 1 1998-08_
35 FT800A.21.058 主离合摇臂轴焊合 MAIN CLUTCH ROCKER SHAFT WELDMENT 1 2008-03_
36 FT800A.21.335a 叉形接头 FORK JOINT 1 2008-07_

37 FT800.21.206 离合踏板回位弹簧 CLUTCH PEDAL RETURN SPRING 1 2011-11_

4 GBT91-3.2X20-A0P 开口销 PIN 4 2011-11_
4 GBT91-3.2X20-A0P 开口销 PIN 4 2011-11_
5 FT800.21.241 拉杆后叉 PULL ROD REAR FORK 1 2011-11_
6 GBT6170-M10-A3L 螺母 NUT 1 2011-11_

7 FT800.21.212 限位座 LIMITING SEAT 1 2011-11_

8 GBT5783-M10X25-A3L 螺栓 BOLT 2 2011-11_
9 GBT93-10-A0P 标准型弹簧垫圈 WASHER 2 2011-11_

164
 TD824-1F161F23K拖拉机

165
 TD824-1F161F23K拖拉机

FT800A.21C.002-3 21.3-离合器操纵总成-3 CLUTCH CONTROL ASSEMBLY-3

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT894.1-30 挡圈 RETAINER RING 1 2011-11_

10 GBT848-10-A0P 小垫圈 WASHER 2 2011-11_
11 FT800A.21.061 主离合短拉杆焊合 MAIN CLUTCH SHORT PULL ROD WELDMENT 1 2011-11_
12 GBT6171-M10X1-LH-A2L 螺母 NUT 1 2011-11_
13 FT800A.21.353 中间杆 MIDDLE ROD 1 2011-11_

14 GBT6171-M10X1-A2L 螺母 NUT 3 2011-11_

15 FT800A.21.060 主离合长拉杆焊合件 MAIN CLUTCH LONG PULL ROD WELDMENT 1 2011-11_
16 FT800A.21.072 过渡杠杆压合件 TRANSITION LEVER PRESSURE UNIT 1 2011-11_
16 FT800A.21.072 过渡杠杆压合件 TRANSITION LEVER PRESSURE UNIT 1 2011-11_
16.1 FT800A.21.073 过渡杠杆焊合件 TRANSITION LEVER WELDMENT 1 2011-11_

16.2 FT800A.21.380 支承轴衬套 SUPPORT SHAFT BUSH 2 2011-11_

17 FT800A.21.074 过渡杠杆支撑轴焊合 TRANSITION LEVER SUPPORT SHAFT 1 2011-11_
18 GBT5783-M8X20-A2L 螺栓 WELDMENT 1 2011-11_
19 FT800A.21.373 回位弹簧 BOLT 1 2011-11_
2 FT800A.43.305 隔套 RETURN SPRING 2 2011-11_
SPACER BUSH
20 GBT6170-M10-A3L 螺母 1 2011-11_
21 FT800.43.030 调整螺钉 NUT 1 2011-11_
22 FT800.21.215 副离合回位弹簧 ADJUSTING SCREW 1 2011-11_
24 FT800A.21.061 主离合短拉杆焊合 AUXILIARY CLUTCH RETURN SPRING 1 2011-11_
25 FT800A.21.353 中间杆 MAIN CLUTCH SHORT PULL ROD WELDMENT 1 2011-11_
MIDDLE ROD
26 FT800A.21.060 主离合长拉杆焊合件 1 2011-11_
27 GBT5783-M8X20-8.8-A2L 六角头螺栓 MAIN CLUTCH LONG PULL ROD WELDMENT 1 2011-06_
28 GBT93-8-AOP 弹簧垫圈 BOLT 12 2011-11_
29 GBT6170-M8-8-A2L Ⅰ型六角螺母 SPRING WASHER 8 2011-06_
3.1 FT800A.21.308 离合踏板毂衬套 I-TYPE HEXAGON NUT 1 1998-08_

166
 TD824-1F161F23K拖拉机

167
 TD824-1F161F23K拖拉机

FT800A.21C.002-3 21.3-离合器操纵总成-3(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

3.1 FT800A.21.385 离合踏板毂衬套 CLUTCH PEDAL HUB BUSH 1 2010-10_

3.2 FT800A.21.050 离合摇臂焊合 CLUTCH ROCKER WELDMENT 1 2011-11_
30 FT800A.21.049 离合踏板支承轴焊合 CLUTCH PEDAL SUPPORTING SHAFT 1 2011-11_
31 FT800A.43.305 隔套 WELDMENT 2 2011-11_
32 GBT894.1-20 挡圈20 SPACER BUSH 1 2011-11_
BLCOKING RING
33 GBT848-20-A0P 小垫圈 1 2009-04_
34 FT800A.21.040 过渡杠杆合件 WASHER 1 2011-11_
35 FT800A.21.332 小隔套 TRANSITION LEVER UNIT 1 2011-11_
36 FT800A.21.052 转轴支座焊合总成 SMALL SPACER BUSH 1 2011-11_
4 GBT6170-M8-A2L 螺母 ROTARY SHAFT SEAT WELDMENT ASSEMBLY 2 2011-11_
NUT
5 GBT93-8-A0P 垫圈 2 2011-11_
6 GBT97.1-8-A0P 平垫圈 WASHER 1 2011-11_
7 FT800A.21.049 离合踏板支承轴焊合 WASHER 1 2011-11_
8 GBT41-8-A0P 六角螺母 CLUTCH PEDAL SUPPORTING SHAFT 3
9 GBT91-3.2X20-A0P 开口销 WELDMENT 2 2011-11_
HEXAGON NUT
9 GBT91-3.2X20-A0P 开口销 PIN 2 2011-11_

PIN

168
 TD824-1F161F23K拖拉机

169
 TD824-1F161F23K拖拉机

TD804.311 31.1-前桥总成 31.1-FRONT AXLE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 TD804.311-1 前桥总成-1 31FRONT AXLE ASSEMBLY-1 0 2011-11_

0 TD804.311-5 前桥总成-5 31FRONT AXLE ASSEMBLY-5 0 2011-11_
0 TD804.311-5 前桥总成-5 31FRONT AXLE ASSEMBLY-5 0 2011-11_
0 TD804.311-4 前桥总成-4 31FRONT AXLE ASSEMBLY-4 0 2011-11_
0 TD804.311-3 前桥总成-3 31FRONT AXLE ASSEMBLY-3 0 2011-11_

0 TD804.311-2 前桥总成-2 31FRONT AXLE ASSEMBLY-2 0 2011-11_

1 TD804.311.2 前驱动桥前支座总成 FRONT DRIVING AXLE FRONT SEAT ASSEMBLY 1 2011-11_
1.1 FT804.31.108 前驱动桥前支座 FRONT DRIVING AXLE FRONT SEAT 1 2011-11_
1.2 FT804.31.109 前驱动桥前座衬套 FRONT DRIVING AXLE FRONT SEAT BUSH 1 2011-11_
11 TD804.311.1 前驱动桥后支座总成 FRONT DRIVING AXLE REAR SEAT ASSEMBLY 1 2011-11_

11.1 FT804.31.103 前驱动桥后座衬套 FRONT DRIVING AXLE REAR SEAT BUSH 1 2011-11_
11.2 FT804.31.104 前驱动桥后安装座 FRONT DRIVING AXLE REAR INSTALLATION 1 2011-11_
12 FT654.32.104 垫圈 SEAT 16 2011-11_
12 FT654.32.104 垫圈 WASHER 16 2011-11_
13 GBT5786-M16X1.5X40-10.9-A3L 六角头螺栓 WASHER 16 2011-11_
BOLT
3 JBT7940.1-M10X1 直通式压注油杯 3 2011-11_
5 GBT5786-M18X1.5X60-A3L 六角头螺栓 STRAIGHT PRESSURE FILLING OIL CUP 4 2011-11_
7 FT804.31.110 垫环 BOLT 1 2011-11_
7 FT804.31.110 垫环 PAD RING 1 2011-11_
PAD RING

170
 TD824-1F161F23K拖拉机

171
 TD824-1F161F23K拖拉机

TD804.312 31.2-托架总成 31.2-BRACKET ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TD804.312-01 托架 BRACKET 1 2011-11_

2 TD800.312-02 螺栓 BOLT 8 2011-11_
3 GBT93-16-AOP 垫圈 WASHER 8 2011-11_
4 FT800.31.120 托架连接套 BRACKET CONNECTING SLEEVE 2 2011-11_

172
 TD824-1F161F23K拖拉机

173
 TD824-1F161F23K拖拉机

TD800.313A 31.3-托架前体总成 31.3-BRACKET FRONT BODY ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TD800.313A-01 托架前体 BRACKET FRONT BODY 1

2 GBT5783-M16X45-8.8-A3L 六角头螺栓 BOLT 5 2013-07_
3 FT800.34.108 平垫圈 WASHER 1 2011-09_

174
 TD824-1F161F23K拖拉机

175
 TD824-1F161F23K拖拉机

FT804B.32.001 32-前驱动轮总成 32-FRONT DRIVING WHEEL ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT1192-11.2-24-6PR 外胎 OUTER TUBE 2 2011-11_

2 GBT1192-11.2-24 内胎 INNER TUBE 2 2011-11_
3 FT804B.32.010 轮辋辐板合件 RIM SPOKE UNIT 2 2011-11_

176
 TD824-1F161F23K拖拉机

177
 TD824-1F161F23K拖拉机

FT800.34B.001 34-后驱动轮总成 34-REAR DRIVE WHEEL ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT2979-18.4-30-8PR 拖拉机驱动轮普通断面斜交结构外胎 DRIVING WHEEL OUTER TUBE 2 2004-01_

1 GBT1192-18.4-30-10PR-R 拖拉机驱动轮普通断面斜交结构外胎 DRIVING WHEEL OUTER TUBE 2 2010-05_
2 GBT2979-18.4-30 拖拉机驱动轮内胎 DRIVING WHEEL INNER TUBE 2 2004-01_
3 FT800.34B.011 轮辋总成 RIM ASSEMBLY 2 2011-11_

178
 TD824-1F161F23K拖拉机

179
 TD824-1F161F23K拖拉机

FT800.35.001 35-牵引装置总成 35-TOWING MECHANISM ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.35.112 弹性锁销 SPRING LOCK PIN 2 2011-11_

10 FT65.35.103 弹性锁销 SPRING LOCK PIN 2 2011-11_
10 FT65.35.103 弹性锁销 SPRING LOCK PIN 2 2011-11_
11 FT800.35.103 摆杆 UPPER PART U-HOOK 1 2011-11_
12 FT800.35.109 牵引销 HITCH PIN 1 2011-11_

13 FT800.35.104 弯板 BENDING PLATE 1 2011-11_

13 FT800.35.104 弯板 BENDING PLATE 1 2011-11_
14 GBT5782-M16X90-A2L 六角头螺栓 BOLT 2 2011-11_
2 GBT899-GM16-M16X110-A2L 双头螺柱 8.8-A3L STUD 6 2011-11_
3 FT800.35.012 下拉杆支座底板焊合 LOWER LINK SEAT BOTTOM PLATE 1 2011-11_

4 FT800.35.102 限位销 LIMITING PIN 2 2011-11_

5 FT800.35.011 支承架焊合 BRACKET WELDMENT 1 2011-11_
6 GBT899-GM16-M16X40-A2L 双头螺柱 8.8-A3L STUD 6 2011-11_
7 GBT93-16-AOP 垫圈 WASHER 14 2013-07_
8 GBT6170-M16-AOP 螺母 NUT 14 2013-07_

9 FT800.35.101 摆销 SWING PIN 1 2011-11_

180
 TD824-1F161F23K拖拉机

181
 TD824-1F161F23K拖拉机

TD800A.371C 37.1-变速箱壳体总成 37.1-GEARBOX HOUSING ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TD800A.371C-01 变速箱壳体 GEAR BOX 1 2011-11_

10 FT800A.37.181 检视窗盖 INSPECTION WINDOW COVER 1 2011-11_
12 GBT91-5X25-A0P 开口销 PIN 1 2011-11_
13 TD800A.371C-02 专用螺栓 SPECIAL BOLT 4 2011-11_
14 FT800.37.198 分离叉轴衬套 RELEASE FORK SHAFT BUSH 4 2011-11_

15 GBT899-AM12-M12X1.5X40-A3L 双头螺柱 8.8-A3L STUD 10 2011-03_

16 SPL6177.2-M12X1.5-F3 六角法兰面螺母 NUT 10 2011-11_
17 GBT899-AM16-M16X1.5X40-10.9-A3L 双头螺柱 8.8-A3L STUD 2 2011-03_
17 GBT899-AM16-M16X1.5X45-A3L 双头螺柱 8.8-A3L STUD 2 2008-06_
18 SPL6177.2-M16X1.5-F3 六角法兰面螺母 NUT 2 2011-11_

19 GBT119.1-16m6X28-A0P 圆柱销 PIN 2 2011-11_

2 GBT5783-M12X40-A3L 螺栓 BOLT 5 2011-11_
20 GBT5782-M12X65-10.9-A2L 六角头螺栓 BOLT 2 2004-01_
20 GBT5782-M12X65-10.9-A2L 六角头螺栓 BOLT 2 2004-01_
21 GBT6170-M16-A3L 螺母 M16-A3L NUT 4 2011-11_

22 GBT5783-M16X45-8.8-A3L 六角头螺栓 BOLT 1 2013-04_

3 GBT93-12-A0P 弹簧垫圈 SPRING WASHER 11 2011-11_
4 GBT5783-M10X50-A3L 六角头螺栓 BOLT 1
4 GBT5783-M10X40-10.9-A3L 六角头螺栓 BOLT 1 2009-05_
5 GBT93-10-A0P 标准型弹簧垫圈 WASHER 1 2011-11_

6 FT800.37.316 橡胶塞 RUBBER RING 1 2011-11_

7 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 9 2011-11_
8 GBT5782-M16X90-A2L 六角头螺栓 BOLT 2 2011-11_
9 GBT70.1-M16X80-10.9-A3L 内六角圆柱头螺钉 SCREW 2 2004-01_
9 GBT70.1-M16X80-10.9-A3L 内六角圆柱头螺钉 SCREW 2 2004-01_

182
 TD824-1F161F23K拖拉机

183
 TD824-1F161F23K拖拉机

TD800A.372G-1 37.2.1-主副变速总成-1 MAIN/ASSISTANT GEAR ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.37C.107 输入轴轴承座 INPUT SHAFT BEARING SEAT 1 2011-11_

10 FT800.37.117C 衬套 SLEEVE 1 2011-11_
12 TD800A.372F-02 Ⅲ档主动齿轮 Ⅲ DRIVING GEAR 1 2011-11_
2 GBT9877.1-FB50X72X8F 内包骨架旋转轴唇形密封 O RING 2 2011-11_
3 FT800.37.172 调整垫片 ADJUSTING WASHER 999 2011-11_

4 GBT276-6310 轴承 BEARING 1 2011-11_

5 GBT5783-M10X25-A3L 螺栓 BOLT 4 2011-11_
6 GBT93-10-AOP 标准型弹簧垫圈 WASHER 4 2011-11_
7 FT800.37C.011 输入轴总成 INPUT SHAFT ASSEMBLY 1 2011-11_
8 GBT894.1-55 轴用弹性挡圈 SNAP RING 1 2011-11_

9 TD800A.372F-01 Ⅱ档主动齿轮 Ⅱ DRIVING GEAR 1 2011-11_

184
 TD824-1F161F23K拖拉机

185
 TD824-1F161F23K拖拉机

TD800A.372G-2 37.2.2-主副变速总成-2 MAIN/ASSISTANT GEAR ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.37C.104 动力输出前段轴 PTO FRONT SHAFT 1 2011-11_

10 TD800A.372F-04 副变速低档主动齿轮 AUXILIARY LOW DRIVING GEAR 1 2011-11_
11 QSFZ-B019-K55X62X46ZW 滚针轴承 NEEDLE BEARINGS 1 2004-01_
11 QLWZB120-K55X62X46ZW 滚针轴承 NEEDLE BEARINGS 1 2010-03_
12 TD800A.372F-05 副变速低档啮合套 AUXILIARY LOW GEAR SHIFT COLLAR 1 2011-11_

13 TD800A.372F-06 梭式换档主动齿轮 SHUTTLE SHIFT DRIVING GEAR 1 2011-11_

14 TD800A.372F-07 中间轴档圈 MIDDLE SHAFT RETAINER RING 1 2011-11_
15 GBT276-6408N 深沟球轴承 BEARING 1 2011-11_
16 GBT305-110-116.6 止动环 THRUST RING 1 2004-01_
17 GBT894.1-40 挡圈40 WASHER 40 1 2011-11_

2 FT800.37.118 Ⅲ-Ⅳ档啮合套 Ⅲ-Ⅳ SHIFT COLLAR 1 2011-11_

3 FT800.37.119 Ⅲ-Ⅳ档啮合齿座 Ⅲ-Ⅳ ENGAGING GEAR SEAT 1 2011-11_
4 TD800A.372F-15 轴承 BEARING 1 2011-11_
5 FT800.37.106 动力输出轴连接套 PTO SHAFT CONNECTING SLEEVE 1 2011-11_
6 GBT893.1-28 挡圈 RETAINER RING 1 2011-11_

7 TD800A.372F-03 梭式换档中间轴 SHUTTLE SHIFT MIDDLE SHAFT 1 2011-11_

8 TD800A.372F-16 轴承 BEARING 1 2011-11_
8 TD800A.372F-16 轴承 BEARING 1 2011-11_
9 GBT894.1-70 轴用弹性挡圈 SNAP RING 1 2011-11_

186
 TD824-1F161F23K拖拉机

187
 TD824-1F161F23K拖拉机

TD800A.372G-3 37.2.3-主副变速总成-3 MAIN/ASSISTANT GEAR ASSEMBLY-3

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M10X25-A3L 螺栓 BOLT 4 2011-11_

10 FT800.37.178C 中间轴止推环 MIDDLE SHAFT THRUST RING 1 2011-11_
11 FT800.37.124C Ⅰ档从动齿轮 I DRIVEN GEAR 1 2011-11_
12 QSFZB019-K64X74X41ZW 滚针轴承 NEEDLE BEARINGS 2 2004-01_
13 FT800.37.123C 衬套 SLEEVE 1 2011-11_

14 FT800.37.209C 隔套二 SPACER BUSH 2 1 2011-11_

15 FT800.37.118 Ⅲ-Ⅳ档啮合套 Ⅲ-Ⅳ SHIFT COLLAR 1 2011-11_
16 FT800.37.119 Ⅲ-Ⅳ档啮合齿座 Ⅲ-Ⅳ ENGAGING GEAR SEAT 1 2011-11_
17 TD800A.372F-14 Ⅱ挡从动齿轮 Ⅱ DRIVEN GEAR 1 2011-11_
18 FT800.37.117C 衬套 SLEEVE 1 2011-11_

19 TD800A.372F-13 Ⅲ挡从动齿轮 Ⅲ DRIVEN GEAR 1 2011-11_

2 GBT93-10-A0P 标准型弹簧垫圈 WASHER 4 2011-11_
20 FT800.37.176 中间轴隔套 MIDDLE SHAFT SPACER BUSH 1 2011-11_
21 TD800A.372F-11 Ⅳ档从动齿轮 Ⅳ DRIVEN GEAR 1 2011-11_
22 GBT283-NUP211E 圆柱滚子轴承 BEARING 1 2011-11_

23 TD800A.372F-12a 中间轴 MIDDLE SHAFT 1 2013-07_

23 TD800A.372F-12 中间轴 MIDDLE SHAFT 1 2011-11_
3 FT800.37.179 中间轴端盖 MIDDLE SHAFT END COVER 1 2011-11_
4 FT800A.37A.244 热镀锌钢丝 ZINC-COATED STEEL WIRE 1 2011-11_
5 TD800A.372-01 专用螺栓 SPECIAL BOLT 2 2011-11_

6 FT800.37.187 挡圈 RETAINER RING 1 2011-11_

7 GBT305-90-96.5 止动环 THRUST RING 1 2011-11_
8 GBT276-6210 深沟球轴承 BEARING 1 2010-12_
8 GBT276-6210N 深沟球轴承 BEARING 1 2011-11_
9 FT804.42.109 调整垫片 ADJUSTING WASHER 999 2011-11_

188
 TD824-1F161F23K拖拉机

189
 TD824-1F161F23K拖拉机

TD800A.372G-4 37.2.4-主副变速总成-4 MAIN/ASSISTANT GEAR ASSEMBLY-4

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.37.175 滚针轴承隔圈 NEEDLE BEARING SPACER RING 2 2011-11_

10 FT800.37.206 调整垫片 ADJUSTING WASHER 999 2011-11_
11 GBT276-6211 深沟球轴承 BEARING 1 2011-11_
12 GBT305-100-106.5 止动环 THRUST RING 1 2011-11_
13 TD800A.372F-08a 输出轴 OUTPUT SHAFT 1 2013-07_

13 TD800A.372F-08 输出轴 OUTPUT SHAFT 1 2011-11_

14 TF1004.372.2 惰轮轴总成 IDLER SHAFT ASSEMBLY 1 2011-06_
14 FT800.37D.023 惰轮轴总成 IDLER SHAFT ASSEMBLY 1 2004-01_
14.1 QCT387-14 塞片 PLUG PIECE 1 2011-11_
14.2 TF1004.372.2-01 惰轮轴 IDLER SHAFT 1 2011-06_

14.2 FT800.36D.136 惰轮轴 IDLER SHAFT 1 2004-01_

15 FT800.37D.232 惰轮隔套 IDLER SHAFT SPACER BUSH 1 2011-11_
16 QLWZB120-K35X45X43ZW 滚针轴承 NEEDLE BEARINGS 1 2010-03_
16 QSFZB019-K35X45X43ZW 滚针轴承 NEEDLE BEARINGS 1 2004-01_
17 FT800.37D.326 惰轮 IDLER 1 2011-11_

18 FT800.37D.233 档圈 RETAINER RING 1 2011-11_

19 FT65.38.026 油塞总成 Oil Plug assembly 1 2011-11_
19 FT65.38.026 油塞总成 Oil Plug assembly 1 2011-11_
2 TD800A.372F-17 滚针轴承 NEEDLE BEARINGS 1 2011-11_
3 TD800A.372F-09 梭式换档啮合齿套 MESHING BUSH OF SHUTTLE GEAR 1 2011-11_

4 TD800A.372F-10 梭式换档啮合齿座 SHUTTLE SHIFT SHIFT GEAR SEAT 1 2011-11_

5 FT800.37D.240 隔套 SPACER BUSH 1 2011-11_
6 FT800.37D.128 梭式换档从动齿轮 SHUTTLE SHIFT DRIVEN GEAR 1 2011-11_
7 QSFZB019-K55X65X43ZW 滚针轴承 NEEDLE BEARINGS 1 2004-01_
8 FT800.37D.190 止推环挡圈 THRUST RETAINER RING 1 2004-01_

190
 TD824-1F161F23K拖拉机

191
 TD824-1F161F23K拖拉机

TD800A.372G-4 37.2.4-主副变速总成-4(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

8 TF1004.372A-03 止推环挡圈 THRUST RETAINER RING 1 2012-11_

9 FT800.37D.236 止推环 PLATE;THRUST 1 2011-11_

192
 TD824-1F161F23K拖拉机

193
 TD824-1F161F23K拖拉机

TD800A.373B-1 37.3.1-侧置操纵总成-1 SIDE CONTROL ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.37.154 Ⅰ-Ⅱ档拨杆 I-II GEAR DIAL ROD 1 2011-11_

1 FT800.37.154 Ⅰ-Ⅱ档拨杆 I-II GEAR DIAL ROD 1 2011-11_
10 FT800.37.177 互锁销 MUTUAL PIN 2 2011-11_
11 FT800A.37.320a 副变速拨叉轴 AUXILIARY GEARSHIFT FORK SHAFT 2 2011-11_
12 FT800.37.139 弹簧 SPRING 4 2011-11_

13 GBT308-10-G100-b 钢球 BALL 4 2011-11_

14 TD800A.373B-03 副变速低档拨叉 AUXILIARY LOW GEAR FORK 1 2011-11_
2 TD800A.373B-05 Ⅰ-Ⅱ档拨头 I-II GEAR FORK HEAD 1 2011-11_
3 FT800.37.194 紧定螺钉 LOCKING SCREW 6 2011-11_
4 FT800.37.015B 主变速操纵手柄球总成 MAIN GEARSHIFT HANDLE BALL ASSEMBLY 1 2011-08_

4 FT800A.37A.244 热镀锌钢丝 ZINC-COATED STEEL WIRE 6 2011-11_

5 FT800A.37.318 Ⅰ-Ⅱ挡叉轴 I- II GEAR FORK SHAFT 1 2011-11_
6 FT800.37.158 Ⅲ-Ⅳ档拨叉 Ⅲ-Ⅳ FORK 1 2011-11_
7 TD800A.373B-01 Ⅲ-Ⅳ挡拨头 Ⅲ-Ⅳ GEAR FORK HEAD 1 2011-11_
8 FT800A.37.319 Ⅲ-Ⅳ挡叉轴 Ⅲ-Ⅳ GEAR FORK SHAFT 1 2011-11_

9 TD800A.373B-02 梭式换档拨杆 SHUTTLE SHIFT DIAL ROD 1 2011-11_

194
 TD824-1F161F23K拖拉机

195
 TD824-1F161F23K拖拉机

TD800A.373B-2 37.3.2-侧置操纵总成-2 SIDE CONTROL ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TD800A.373B.1.1 副变速操纵手柄总成 AUXILIARY GEARSHIFT CONTROL HANDLE 1 2011-11_

10 TD800A.373B.1-03 副变速操纵杆 ASSEMBLY 1 2011-11_
10 TD800A.373B.1-03a 下操纵杆 AUXILIARY GEARSHIFT CONTROL ROD 1 2011-08_
11 TD800A.373B.1-05 下操纵杆 LOWER CONTROL ROD 1 2011-11_
12 FT800A.37.307 橡胶套 LOWER CONTROL ROD 2 2011-11_
RUBBER SLEEVE
13 GBT5781-M10X20-A3L 六角头螺栓 6 2011-11_
14 GBT93-10-A0P 标准型弹簧垫圈 BOLT 6 2011-11_
15 TD800A.373B.1-04 副变速变速杆支座 WASHER 1 2011-11_
16 Q722-24 碗形塞片 AUXILIARY GEARSHIFT LEVER SEAT 2 2011-11_
17 FT800A.37.326 变速杆定位销 PLUG PIECE 4 2011-11_
GEARLEVER LOCATING PIN
18 TF1004.374-02 低碳钢丝 2 2011-11_
19 FT800A.37N.308a 侧操纵盖 LOW CARBON STEEL WIRE 1 2011-11_
2 GBT6170-M10-A3L 螺母 SIDE CONTROL COVER 2 2011-11_
20 FT800A.37.309a 侧操纵下盖 NUT 1 2011-08_
20 FT800A.37.309 侧操纵下盖 SIDE CONTROL LOWER COVER 1 2004-01_
SIDE CONTROL LOWER COVER
21 GBT93-8-A0P 垫圈 8 2011-11_
22 GBT5781-M8X20-A2L 六角头螺栓 WASHER 8 2011-11_
22 GBT5781-M8X20-A2L 六角头螺栓 BOLT 8 2011-11_
23 TD800A.373B.1-02B 变速杆操纵拨头 BOLT 1 2011-08_
23 TD800A.373B.1-02c 变速杆操纵拨头 GEARSHIFT LEVER CONTROL DIAL HEAD 1 2012-01_
GEARSHIFT LEVER CONTROL DIAL HEAD
23 TD800A.373B.1-02a 副变速操纵拨头 1 2004-01_
24 FT800A.37.311 弹簧 AUXILIARY GEARSHIFT CONTROL DIAL HEAD 2 2011-11_
25 FT800A.37.314 隔套 SPRING 1 2011-11_
26 TD800A.373B.1-01 副变速操纵传递杆 SPACER BUSH 1 2011-11_
26 TD800A.373B.1-01b 副变速操纵传递杆 AUXILIARY GEARSHIFT CONTROL 1 2012-01_

196
 TD824-1F161F23K拖拉机

197
 TD824-1F161F23K拖拉机

TD800A.373B-2 37.3.2-侧置操纵总成-2(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

26 TD800A.373B.1-01 副变速操纵传递杆 AUXILIARY GEARSHIFT CONTROL 1 2011-11_

27 GBT3452.1-18.0X2.65G 液压气动用O形橡胶密封圈 TRANSMISSION ROD 2 2011-11_
28 FT800A.37.315 内操纵拨头 O-SEAL RING 2 2004-01_
28 FT800A.37.315a 内操纵拨头 INNER CONTROL FORK HEAD 2 2012-01_
29 GBT879.1-8X32 弹性圆柱销 INNER CONTROL FORK HEAD 4 2011-11_
PIN
3 TD800A.373B.1.3a 副变速操纵杆焊合 1 2011-11_
3 TD800A.373B.1.3b 副变速操纵杆焊合 AUXILIARY GEARSHIFT CONTROL ROD 1 2011-08_
30 GBT879.1-3X32 弹性圆柱销 WELDMENT 1 2011-11_
31 FT800A.37.310 外操纵拨头 AUXILIARY GEARSHIFT CONTROL ROD 1 2011-11_
31 FT800A.37.310a 外操纵拨头 WELDMENT 1 2012-01_
PIN
32 FT800A.37.312 主变速操纵传递杆 OUTER CONTROL FORK HEAD 1 2004-01_
32 FT800A.37.312b 主变速操纵传递杆 OUTER CONTROL FORK HEAD 1 2012-01_
32 FT800A.37.312a 主变速操纵传递杆 1 2011-08_
33 GBT879.1-5X30 弹性圆柱销 MAIN GEARSHIFT CONTROL TRANSFER ROD 2 2011-11_
34 GBT879.1-3X30 弹性圆柱销 MAIN GEARSHIFT CONTROL TRANSFER ROD 2 2011-11_
MAIN GEARSHIFT CONTROL TRANSFER ROD
4 FT800.37.015a 主变速操纵手柄总成 PIN 1 2004-01_
5 TD800A.373B.1.2a 主变速操纵杆焊合 PIN 1 2004-01_
5 TD800A.373B.1.2b 主变速操纵杆焊合 1 2011-08_
6 GBT879.1-8X35 弹性圆柱销 MAIN GEARSHIFT CONTROL HANDLE ASSEMBLY 2 2011-11_
7 GBT879.1-5X32 弹性圆柱销 MAIN GEARSHIFT CONTROL ROD WELDMENT 7 2011-11_
MAIN GEARSHIFT CONTROL ROD WELDMENT
8 GBT893.1-40 挡圈 PIN 2 2011-11_
9 FT800A.37.305 尼龙座 PIN 2 2011-11_

RETAINER RING
NYLON SEAT

198
 TD824-1F161F23K拖拉机

199
 TD824-1F161F23K拖拉机

TD800A.373B-3 37.3.3-侧置操纵总成-3 SIDE CONTROL ASSEMBLY-3

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TF1004.452-11 密封套 SEAL SLEEVE 1 2011-11_

10 QCT387-14-A0P 塞片 PLUG PIECE 1 2011-11_
11 FT800.37.161c Ⅰ-Ⅱ档拨叉 I-II GEAR FORK 1 2011-11_
12 FT800.37.153 中间拨叉轴 MIDDLE FORK SHAFT 1 2011-11_
13 TD800A.373B-04 副变速拨叉 AUXILIARY GEARSHIFT FORK 1 2004-01_

13 TF1004.373-02 副变速拨叉 AUXILIARY GEARSHIFT FORK 1 2011-01_

13 TF1004.373-02 副变速拨叉 AUXILIARY GEARSHIFT FORK 1 2011-01_
2 TD800A.373-01 专用螺栓 SPECIAL BOLT 2 2011-11_
3 GBT93-10-A0P 标准型弹簧垫圈 WASHER 11 2011-11_
4 GBT5783-M10X25-A3L 螺栓 BOLT 8 2011-11_

5 FT800.37.169 定位板 LOCATING PLATE 1 2011-11_

6 GBT5783-M10X20-A3L 螺栓 BOLT 1 2011-11_
7 FT800A.37.327 换档限位板 GEARSHIFT LIMITING PLATE 1 2011-11_
8 GBT93-8-A0P 垫圈 WASHER 2 2011-11_
9 GBT5781-M8X20-A2L 六角头螺栓 BOLT 2 2011-11_

9 GBT5781-M8X20-A2L 六角头螺栓 BOLT 2 2011-11_

200
 TD824-1F161F23K拖拉机

201
 TD824-1F161F23K拖拉机

TD800A.374B 37.4-爬行档机构总成 37.4-CREEPER GEAR MECHANISM ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT65.38.051 拉压手柄 PULL/PRESS HANDLE 1 2011-11_

11 FT800A.37A.040 爬行档摇臂焊合 CREEPER ROCKER WELDMENT 1 2011-11_
12 FT800.37.169 定位板 LOCATING PLATE 1 2011-11_
13 GBT5781-M10X20-A3L 六角头螺栓 BOLT 1 2011-11_
14 FT800.37D.210 内齿圈 INNER GEAR RING 1 2011-11_

15 GBT5783-M10X25-A3L 螺栓 BOLT 6 2011-11_

16 FT800.37D.230 耐磨垫片 WEARABLE WASHER 2 2011-11_
17 FT800.37D.018 行星架总成 PLANET CARRIER ASSEMBLY 1 2011-11_
17.1 FT800.37A.024 行星架焊合 PLANET CARRIER WELDMENT 1 2011-11_
17.11 FT800.37A.217 行星架 PLANET CARRIER 1 2011-11_

17.12 FT800.37A.226 行星齿座内齿环 INNER GEAR RING OF PLANET GEAR 1 2011-11_

17.2 FT800.37A.213 行星齿轮轴 PLANET GEAR SHAFT 3 2011-11_
17.3 FT800.37A.212 行星齿轮衬圈 PLANET GEAR LINER 6 2011-11_
17.4 FT800.37A.214 滚针隔圈 NEEDLE SPACER RING 6 2011-11_
17.5 GBT309-4X25.8 滚针 NEEDLE 57 2011-11_

17.6 FT800.37D.211 行星齿轮 PLANETARY GEAR 3 2011-11_

18 FT800.37D.216 行星架垫板 PLANET CARRIER MAT PLATE 1 2011-11_
19 GBT893.1-170 孔用弹性挡圈 SNAP RING 1 2011-11_
2 GBT6172.1-M10-A3L 螺母 NUT 3 2011-11_
20 FT800.37A.218 爬行档接合套 CREEPER GEAR CONNECTING SLEEVE 1 2011-11_

21 FT800.37A.225 高低档拨叉 HIGH AND LOW GEAR FORK 1 2011-11_

22 FT800.37.194 紧定螺钉 LOCKING SCREW 2 2011-11_
23 FT800A.37A.244 热镀锌钢丝 ZINC-COATED STEEL WIRE 2 2011-11_
24 GBT6172.1-M12-A3L 螺母 NUT 1 2011-11_
25 GBT71-M12X40-A3L 开槽锥端紧定螺钉 SCREW 1 2011-11_

202
 TD824-1F161F23K拖拉机

203
 TD824-1F161F23K拖拉机

TD800A.374B 37.4-爬行档机构总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

26 FT800.37.139 弹簧 SPRING 1 2011-11_

27 GBT308-10-G100-b 钢球 BALL 1 2011-11_
28 FT800.37A.220 爬行档拨叉轴 CREEPER GEAR FORK SHAFT 1 2011-11_
29 TD800A.374B-01 爬行挡拨头 CREEPER GEAR FORK HEAD 1 2011-11_
3 FT800A.37A.242 拉杆 PULL ROD 1 2011-11_

30 FT800A.37A.224 爬行挡摇臂 CREEPER GEAR ROCKER 1 2011-11_

4 FT65.43.134 右旋连接叉 RIGHT REVOLVING CONNECTING FORK 1 2011-11_
5 GBT91-3.2X22-A0P 开口销 PIN 1 2011-11_
6 GBT97.1-10-A0P 平垫圈 WASHER 1 2011-11_
7 GBT3452.1-17.0X1.80G 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_

8 FT800A.37A.243 拉杆 PULL ROD 1 2011-11_

8 FT800A.37A.243 拉杆 PULL ROD 1 2011-11_
9 GBT879.1-8X30 弹性圆柱销 PIN 1 2011-11_

204
 TD824-1F161F23K拖拉机

205
 TD824-1F161F23K拖拉机

TD804A.38-1 38.1-后桥箱总成-1 REAR AXLE CASE ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5781-M10X25-A3L 六角头螺栓 BOLT 14 2011-11_

10 FT800A.38.016 摇臂焊合 ROCKER WELDMENT 1 2011-11_
11 FT800A.38.252 转轴 ROTATING SHAFT 1 2011-11_
12 FT800A.38.250 拨块 SHIFTING BLOCK 1 2011-11_
13 FT800A.38.251 安装座 FIX SEAT 1 2011-11_

14 FT800.38.123 压板 PRESSURE PLATE 1 2011-11_

15 FT800.38.124 锁片 LOCK SHIM 1 2011-11_
16 GBT305-7278.6 止动环 THRUST RING 1 2013-07_
17 GBT276-6306N 深沟球轴承 BEARING 1 2011-11_
18 GBT895.2-30 挡圈 RETAINER RING 1 2011-11_

19 GBT119.1-12m6X30-A0P 圆柱销 PIN 2 2011-11_

19 GBT119.1-12m6X30-A0P 圆柱销 PIN 2 2011-11_
2 GBT93-10-A0P 标准型弹簧垫圈 WASHER 12 2011-11_
20 FT800.38.125 动力输出中段轴 MIDDLE SHAFT OF PTO 1 2011-11_
21 FT800.38.101d 后桥箱体 REAR AXLE HOUSING 1 2007-06_

3 FT800.38.102 后桥箱盖 REAR AXLE HOUSING COVER 1 2011-11_

4 FT800A.38.017 踏把焊合 PEDAL WELDMENT 1 2011-11_
5 GBT882-8X24 销轴 PIN 1 2011-11_
6 GBT95-8-AOP 平垫圈 WASHER 3 2013-07_
8 FT800A.38.258 拉杆 PULL ROD 1 2011-11_

9 GBT894.1-20 挡圈20 BLCOKING RING 2 2011-11_

206
 TD824-1F161F23K拖拉机

207
 TD824-1F161F23K拖拉机

TD804A.38-2 38.2-后桥箱总成-2 REAR AXLE CASE ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT879.1-5X40 弹性圆柱销 PIN 1 2011-11_

1 GBT879.1-5X40 弹性圆柱销 PIN 1 2011-11_
10 FT800.38.115 堵塞 PLUG 1 2011-11_
11 TF1004.374-02 低碳钢丝 LOW CARBON STEEL WIRE 1 2011-11_
12 FT800.37.194 紧定螺钉 LOCKING SCREW 2 2011-11_

13 Q72220 碗形塞片 PLUG PIECE 1 2011-11_

14 FT800.38.114 差速锁拨叉 DIFFERENTIAL LOCK FORK 1 2011-11_
15 FT800.38.206 隔套 SPACER BUSH 1 2011-11_
16 FT800.38.112 差速锁弹簧 DIFFERENTIAL LOCK SPRING 1 2011-11_
17 FT800.38.134 衬套 SLEEVE 1 2011-11_

18 GBT6171-M14X1.5-A3L 1型六角螺母 NUT 28 2011-11_

19 GBT93-14-A0P 弹簧垫圈 SPRING WASHER 28 2011-11_
19 GBT93-14-A0P 弹簧垫圈 SPRING WASHER 28 2011-11_
2 GBT879.1-8X40 弹性圆柱销 PIN 1 2011-11_
20 GBT899-AM14-M14X1.5X200-A3L 双头螺柱（禁用） 2 2011-11_

21 FT800.38.221 调整垫片 ADJUSTING WASHER 999 2011-11_

22 FT800.38.113 差速锁啮合套 DIFFERENTIAL LOCK SHIFT COLLAR 1 2011-11_
23 GBT899-AM14-M14X1.5X190-A3L 双头螺柱（禁用） 26 2011-11_
24 FT800.38.108 左轴承座 LEFT BEARING SEAT 1 2011-11_
25 FT800A.38.238 螺栓 BOLT 2 2004-01_

25 TD800A.38-01 螺栓 BOLT 2 2009-03_

26 FT800.38.014 放油螺塞总成 OIL DISCHARGING SCREW PLUG ASSEMBLY 1 2011-11_
26.1 GBT5781-M10X25-Zn.D 六角头螺栓 BOLT 1 2013-07_
26.3 FT800.38.144 磁铁压紧垫圈 MAGNET PRESSURE WASHER 2 2011-11_
26.4 FT800.38.145 隔磁铝套 SPACING MAGNETISM ALUMINUM SLEEVE 1 2011-11_

208
 TD824-1F161F23K拖拉机

209
 TD824-1F161F23K拖拉机

TD804A.38-2 38.2-后桥箱总成-2(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

26.5 FT800.38.143 磁铁 MAGNET 1 2011-11_

26.6 JBT982-36 组合密封垫圈 COMBINED SEAL GASKET 1 2011-11_
26.7 FT800.38.141 放油螺塞 OIL DISCHARGING SCREW PLUG 1 2011-11_
3 FT800.38.109 拨块 SHIFTING BLOCK 1 2011-11_
4 FT800.38.111 差速锁拨叉轴 DIFFERENTIAL LOCK FORK SHAFT 1 2011-11_

5 GBT3452.1-20X2.65G 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_

6 FT800A.38.259 套筒 SLEEVE 1 2011-11_
6 FT800A.38.259 套筒 SLEEVE 1 2011-11_
7 GBT3452.1-30X2.65G 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_
8 FT800.38.106 右轴承座 RIGHT BEARING SEAT 1 2011-11_

9 GBT3452.1-17X2.65G 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_

210
 TD824-1F161F23K拖拉机

211
 TD824-1F161F23K拖拉机

TD804A.38-3 38.3-后桥箱总成-3 REAR AXLE CASE ASSEMBLY-3

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 FT800.38.012 差速器总成 DIFFERENTIAL ASSEMBLY 1 2011-11_

1 FT800.38.216 行星齿轮垫片 PLANET GEAR WASHER 4 2011-11_
10 GBT297-32216 圆锥滚子轴承 BEARING 1 2011-11_
10 GBT297-32216 圆锥滚子轴承 BEARING 1 2011-11_
11 GBT5783-M12X25-A3L 六角头螺栓 BOLT 8 2011-11_

12 FT800.38.218 锁片 LOCK SHIM 4 2011-11_

13 FT800.38.132 中心环 CENTRAL RING 1 2011-11_
14 FT800.38.210 半轴齿轮垫片 HALF SHAFT GEAR WASHER 2 2011-11_
15 FT800.38.130 半轴齿轮 HALF SHAFT GEAR 2 2011-11_
16 FT800.38.129 大圆锥齿轮 BIG TAPER GEAR 1 2011-11_

17 FT800.38.133 差速器盖 DIFFERENTIAL HOUSING 1 2011-11_

18 GBT297-30216 圆锥滚子轴承 BEARING 1 2011-11_
2 FT800.38.217 行星齿轮 PLANETARY GEAR 4 2011-11_
3 FT800.38.215 行星齿轮轴 PLANET GEAR SHAFT 1 2011-11_
4 FT800.38.211 大圆锥齿轮固定螺钉 LOCKING BOLT 4 2011-11_

5 FT800.38.212 行星齿轮轴止动螺钉 PLANET GEAR SHAFT THRUST SCREW 4 2011-11_

6 FT800.38.213 锁片 LOCK SHIM 4 2011-11_
7 GBT6171-M14X1.5-A3L 1型六角螺母 NUT 8 2011-11_
8 FT800.38.131 短行星齿轮轴 SHORT PLANETARY GEAR SHAFT 2 2011-11_
9 FT800.38.128 差速器壳体 DIFFERENTIAL HOUSING 1 2011-11_

212
 TD824-1F161F23K拖拉机

213
 TD824-1F161F23K拖拉机

TD804A.38-4 38.4-后桥箱总成-4 REAR AXLE CASE ASSEMBLY-4

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.38.011 小圆锥齿轮总成 SMALL TAPER GEAR ASSEMBLY 1 2011-11_

1.1 FT800.38.207 圆螺母 ROUND NUT 2 2011-11_
1.2 GBT858-50 止动垫圈 WASHER 1 2011-11_
1.3 GBT297-30310 圆锥滚子轴承 BEARING 1 2011-11_
1.4 FT800.38.205 小圆锥齿轮轴承座 SMALL TAPER GEAR BEARING SEAT 1 2011-11_

1.5 GBT297-32311 圆锥滚子轴承 BEARING 1 2011-11_

1.6 FT800.38.126 小圆锥齿轮 SMALL TAPER GEAR 1 2011-11_
2 GBT5783-M12X35-A3L 螺栓 BOLT 4 2011-11_
2 GBT5783-M12X35-A3L 螺栓 BOLT 4 2011-11_
3 GBT93-12-A0P 弹簧垫圈 SPRING WASHER 4 2011-11_

4 FT800.38.208 调整垫片 ADJUSTING WASHER 999 2011-11_

5 FT800.38.017 后桥加油口盖总成 REAR AXLE FILLING CAP COVER ASSEMBLY 1 2011-11_
5.2 FT800.38.149 加油口盖隔圈 SPACER RING OF OIL FILLING CAP COVER 1 2011-11_
5.3 TA650.502.3-04 海绵 SPONGE 1 2011-11_
5.4 FT800.38.148 加油口橡胶垫 RUBBER GASKET OF OIL FILLING CAP 1 2011-11_

6 FT800.38.103a 后桥加油口管 REAR AXLE FILLING CAP PIPE 1 2011-11_

7 GBT5781-M10X25-A3L 六角头螺栓 BOLT 14 2011-11_
8 GBT93-10-A0P 标准型弹簧垫圈 WASHER 12 2011-11_

214
 TD824-1F161F23K拖拉机

215
 TD824-1F161F23K拖拉机

TD804A.38-5 38.5-后桥箱总成-5 REAR AXLE ASSEMBLY-5

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 Q675B12 A型蜗杆传动式软管环箍 A-TYPE WORM TRANSMISSION HOSE CLAMP 2 2011-11_

10 FT800A.38.018 油尺总成 DIPSTICK ASSEMBLY 1 2011-11_
10.1 FT800A.38.216 油尺把手 DIPSTICK HANDLE 1 2011-11_
10.2 GBT867-2X3 半圆头铆钉 RIVET 2 2011-11_
10.3 FT800A.38.217 油尺 OIL DISTICK 1 2011-11_

10.4 FT800A.38.218 橡胶座 RUBBER SEAT 1 2011-11_

2 Q674-05100 塑料紧箍带 PLASTIC FASTEN STRIP 1 2011-11_
2 Q674-05100 塑料紧箍带 PLASTIC FASTEN STRIP 1 2011-11_
3 FT800A.38.195 呼吸软管 BREATH HOSE 1 2011-11_
4 FT65.55.176 呼吸接头 BREATH JOINT 1 2011-11_

5 JBT982-12 组合密封垫圈 COMBINED SEAL GASKET 1 2011-11_

6 GBT93-8-A0P 垫圈 WASHER 2 2011-11_
7 GBT70.1-M8X25-A2L 内六角圆柱头螺钉 SCREW 2 2011-11_
8 GBT3452.1-15X2.65G 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_
9 FT800A.38.019 油尺管总成 DIPSTICK TUBE ASSEMBLY 1 2011-11_

9.1 FT800A.38.239 油尺管座 OIL DIPSTICK PIPE SEAT 1 2011-11_

9.1 FT800A.38.239 油尺管座 OIL DIPSTICK PIPE SEAT 1 2011-11_
9.2 FT800A.38.235 油尺管 OIL DIPSTICK PIPE 1 2011-11_
9.2 FT800A.38.235 油尺管 OIL DIPSTICK PIPE 1 2011-11_

216
 TD824-1F161F23K拖拉机

217
 TD824-1F161F23K拖拉机

FT800.39.002 39-右最终传动总成 39-RIGHT FINAL TRANSMISSION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT6176-M20X1.5-A3L 2型六角螺母 HEXAGON NUT, TYPE-2 8 2011-11_

10 FT800.39.117 调整垫片 ADJUSTING WASHER 999 2004-01_
10 FT800.39.117a 调整垫片 ADJUSTING WASHER 999 2011-01_
11 FT800.39.104 行星架 PLANET CARRIER 1 2011-11_
12 FT800.39.106b 行星架压板 PLANET CARRIER PRESSURE PLATE 1 2014-05_

12 FT800.39.106 行星架压板 PLANET CARRIER PRESSURE PLATE 1 2008-06_

12 FT800.39.106a 行星架压板 PLANET CARRIER PRESSURE PLATE 1 2011-01_
13 FT800.39.105 行星架固定螺栓 PLANET CARRIER FIXING BOLT 1 2004-01_
13 FT800.39.105a 行星架固定螺栓 PLANET CARRIER FIXING BOLT 1 2007-10_
14 FT800.39.112 止推垫片 THRUST WASHER 1 2004-01_

14 FT800.39.112a 止推垫片 THRUST WASHER 1 2007-10_

15 FT800.39.108 最终传动齿圈 FINAL TRANSMISSION GEAR RING 1 2011-11_
16 FT800.39.114 右半轴 RIGHT HALF SHAFT 1 2011-11_
17 FT800.39.110 行星轮滚针外隔圈 PLANET GEAR ROLL NEEDLE OUTER SPACER 6 2011-11_
18 FT800.39.118 滚针 RING 126 2011-11_
NEEDLE
19 FT800.39.109 滚针内隔圈 3 2011-11_
2 FT800.39.130 垫圈 NEEDLE INNER SPACER RING 8 2011-11_
20 FT800.39.107 行星齿轮 WASHER 3 2011-11_
21 FT800.39.111 行星齿轮轴 PLANETARY GEAR 3 2011-11_
22 GBT879.1-8X32 弹性圆柱销 PLANET GEAR SHAFT 3 2011-11_
PIN
23 GBT879.1-12X32 弹性圆柱销 3 2011-11_
3 FT800.39.101d 驱动轮固定螺栓 PIN 8 2011-11_
4 FT800.39.012 驱动轴焊合件 DRIVING WHEEL FIXING BOLT 1 2011-11_
5 GBT9877.1-FB100X130X12D 内包骨架旋转轴唇形密封 DRIVING SHAFT WELDMENT 2 2007-07_
6 FT800.39.120 油封隔圈 O RING 1 2011-11_

218
 TD824-1F161F23K拖拉机

219
 TD824-1F161F23K拖拉机

FT800.39.002 39-右最终传动总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

7 GBT297-30215 圆锥滚子轴承 BEARING 1 2011-11_

8 FT800.39.103a 半轴壳 HALF SHAFT HOUSING 1 2011-11_
9 GBT297-30214 圆锥滚子轴承 BEARING 1 2011-11_

220
 TD824-1F161F23K拖拉机

221
 TD824-1F161F23K拖拉机

FT800.39.001 39-左最终传动总成 39-LEFT FINAL TRANSMISSION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.39.108 最终传动齿圈 FINAL TRANSMISSION GEAR RING 1 2011-11_

10 GBT879.1-8X32 弹性圆柱销 PIN 3 2011-11_
11 GBT879.1-12X32 弹性圆柱销 PIN 3 2011-11_
12 FT800.39.111 行星齿轮轴 PLANET GEAR SHAFT 3 2011-11_
13 FT800.39.110 行星轮滚针外隔圈 PLANET GEAR ROLL NEEDLE OUTER SPACER 6 2011-11_
RING
14 FT800.39.107 行星齿轮 3 2011-11_
15 FT800.39.118 滚针 PLANETARY GEAR 126 2011-11_
16 FT800.39.109 滚针内隔圈 NEEDLE 3 2011-11_
17 GBT297-30215 圆锥滚子轴承 NEEDLE INNER SPACER RING 1 2011-11_
18 FT800.39.120 油封隔圈 BEARING 1 2011-11_
OIL SEAL SPACER RING
19 GBT9877.1-FB100X130X12D 内包骨架旋转轴唇形密封 2 2011-11_
2 FT800.39.113 左半轴 O RING 1 2011-11_
20 FT800.39.012 驱动轴焊合件 LEFT HALF SHAFT 1 2011-11_
21 FT800.39.101c 驱动轮固定螺栓 DRIVING SHAFT WELDMENT 8 2011-11_
22 FT800.39.130 垫圈 DRIVING WHEEL FIXING BOLT 8 2011-11_
WASHER
23 GBT6176-M20X1.5-LH-A3L 2型六角螺母 8 2011-11_
3 FT800.39.103a 半轴壳 HEXAGON NUT, TYPE-2 1 2011-11_
4 GBT297-30214 圆锥滚子轴承 HALF SHAFT HOUSING 1 2011-11_
4 FT800.39.106a 行星架压板 BEARING 1 2011-01_
5 FT800.39.117 调整垫片 PLANET CARRIER PRESSURE PLATE 999 2011-11_
ADJUSTING WASHER
5 FT800.39.117a 调整垫片 999 2011-01_
6 FT800.39.104 行星架 ADJUSTING WASHER 1 2011-11_
7 FT800.39.106 行星架压板 PLANET CARRIER 1 2008-06_
7 FT800.39.106b 行星架压板 PLANET CARRIER PRESSURE PLATE 1 2014-05_
8 FT800.39.105a 行星架固定螺栓 PLANET CARRIER PRESSURE PLATE 1 2007-10_

222
 TD824-1F161F23K拖拉机

223
 TD824-1F161F23K拖拉机

FT800.39.001 39-左最终传动总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

8 FT800.39.105 行星架固定螺栓 PLANET CARRIER FIXING BOLT 1 2004-01_

9 FT800.39.112 止推垫片 THRUST WASHER 1 2004-01_
9 FT800.39.112a 止推垫片 THRUST WASHER 1 2007-10_

224
 TD824-1F161F23K拖拉机

225
 TD824-1F161F23K拖拉机

FT804A.40A.001-1 40.1-全液压转向总成-1 40FULL HYDRAULIC STEERING ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT804A.40L.011 转向器及方向盘总成 REDIRECTOR AND STEERING WHEEL ASSEMBLY 1 2011-11_

1.1 FT800A.40L.050 转向盘总成 STEERING WHEEL ASSEMBLY 1 2011-11_
1.2 FT650.40.014 喇叭电刷座总成 HORN BRUSH SEAT ASSEMBLY 1 2011-11_
1.3 GBT97.1-16-AOP 垫圈 WASHER 1
1.4 FT800A.40L.034 转向管柱总成 STEERING PIPE COLUMN ASSEMBLY 1 2011-11_

1.5 GBT5783-M10×25-8.8-A3L 六角头螺栓 BOLT 4

1.6 GBT93-10-AOP 标准型弹簧垫圈 WASHER 4 2011-11_
1.7 FT804.40L.032 转向器及阀块总成 REDIRECTOR AND VALVE BLOCK ASSEMBLY 1 2011-11_
10 GBT93-8-AOP 弹簧垫圈 SPRING WASHER 8 2011-11_
11 GBT5781-M8X45-A2L 六角头螺栓 BOLT 3 2011-11_

12 FT800A.40.103 固定板 FIXED PLATE 1 2011-11_

13 GBT6170-M8-A2L 螺母 NUT 3 2011-11_
14 GBT5781-M8X16-A2L 六角头螺栓 BOLT 2 2011-11_
2 FT650.40.102 空心螺栓M20X1.5 HOLLOW BOLT M20X1.5 2 2011-11_
3 JBT982-20 组合密封垫圈 COMBINED SEAL GASKET 6 2011-11_

4 FT800A.40L.015a 高压软管总成3 HIGH PRESSURE HOSE ASSEMBLY 3 2 2010-03_

4 FT800A.40L.015 高压软管总成3 HIGH PRESSURE HOSE ASSEMBLY 3 2
4.5 TD800.402A.1 转向器出油胶管总成 OIL OUTLET HOSE ASSEMBLY OF REDIRECTOR 2 2011-09_
5 FT800A.40L.018a 高压输油胶管总成 HIGH PRESSURE OIL HOSE ASSEMBLY 2 2010-03_
5 FT800A.40L.018 高压输油胶管总成 HIGH PRESSURE OIL HOSE ASSEMBLY 2

6 FT800A.40.019 输油左硬管总成 LEFT OIL PIPE ASSEMBLY 1 2011-11_

7 FT800A.40.024 输油右管总成 OIL CONVEYING RIGHT PIPE ASSEMBLY 1 2011-11_
8 FT650.40.029 油缸右软管总成 OIL CYLINDER RIGHT HOSE ASSEMBLY 2 2004-01_
8 FT804A.40.010 油缸右软管总成 OIL CYLINDER RIGHT HOSE ASSEMBLY 2 2010-03_
8 FT650.40.029a 油缸右软管总成 OIL CYLINDER RIGHT HOSE ASSEMBLY 2 2008-08_

226
 TD824-1F161F23K拖拉机

227
 TD824-1F161F23K拖拉机

FT804A.40A.001-1 40.1-全液压转向总成-1(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

9 FT354.40C.121 双管夹 DOUBLE PIPE CLAMP 6 2011-11_

228
 TD824-1F161F23K拖拉机

229
 TD824-1F161F23K拖拉机

FT804A.40A.001-2 40.2-全液压转向总成-2 40FULL HYDRAULIC STEERING ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.40L.110 空心短螺栓 HOLLOW SHORT BOLT 2 2011-11_

10 GBT93-10-AOP 标准型弹簧垫圈 WASHER 4 2011-11_
11 GBT6170-M10-A3L 螺母 NUT 2 2011-11_
12 GBT5781-M12X30-A3L 六角头螺栓 BOLT 2 2011-11_
13 GBT93-12-AOP 垫圈 WASHER 2 2011-11_

14 GBT5781-M10X20-A3L 六角头螺栓 BOLT 2 2011-11_

15 FT800A.40L.101 进油软管 OIL INLET HOSE 1 2011-11_
16 FT800A.40A.023 油泵吸油钢管总成 OIL PUMP INLET STEEL PIPE WELDMENT 1 2011-11_
17 JBT982-27 组合密封垫圈 COMBINED SEAL GASKET 1 2011-11_
17 JBT982-27 组合密封垫圈 COMBINED SEAL GASKET 1 2011-11_

18 FT700.40G.102 卡套式端直通接头体 STRAIGHT PIPE JOINT BODY 1 2011-11_

19 FT800A.40A.028 转向泵总成 STEERING PUMP ASSEMBLY 1 2011-11_
2 JBT982-20 组合密封垫圈 COMBINED SEAL GASKET 6 2011-11_
20 GBT5781-M10X25-A3L 六角头螺栓 BOLT 2 2011-11_
21 JBT982-18 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_

21 JBT982-18 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_

22 FT700.40G.109 空心螺栓 HOLLOW BOLT 1 2011-11_
23 FT800A.40A.026 油泵输油钢管总成 OIL PUMP STEEL PIPE ASSEMBLY 1 2011-11_
24 GBT5781-M6X30-A2L 六角头螺栓 BOLT 3
25 FT800.40L.108 短油管夹 SHORT OIL PIPE CLAMP 4 2011-11_

26 GBT93-6-AOP 垫圈 WASHER 3
27 GBT6170-M6-A2L 螺母 NUT 3 2011-11_
28 GBT5781-M8X30-A2L 六角头螺栓 BOLT 3 2011-11_
29 FT800A.40L.106 减震块 ABSORBER 1 2011-11_
3 FT800A.40L.111 出油钢管 OIL OUTLET STEEL PIPE 1 2011-11_

230
 TD824-1F161F23K拖拉机

231
 TD824-1F161F23K拖拉机

FT804A.40A.001-2 40.2-全液压转向总成-2(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

30 FT800A.40L.107 垫板 PAD BOARD 1 2011-11_

31 GBT93-8-A2L 标准型弹簧垫圈 WASHER 3
32 GBT6170-M8-A2L 螺母 NUT 3 2011-11_
4 ZBJ15001-d32 喉箍 HOOP 4 2011-11_
5 FT800.40.109 短接管 SHORT CONNECTING PIPE 2 2011-11_

6 FT800A.40L.102 吸油软管 OIL SUCTION HOSE 1 2011-11_

7 FT800A.40L.028 高压软管总成 HIGH PRESSURE HOSE ASSEMBLY 1 2011-11_
8 FT800A.40L.020 转向油箱及呼吸器总成 STEERING OIL TANK AND BREATH ASSEMBLY 1 2011-11_
9 FT800A.40A.017 转向油箱支架总成 STEERING OIL TANK BRACKET ASSEMBLY 1 2011-11_

232
 TD824-1F161F23K拖拉机

233
 TD824-1F161F23K拖拉机

TD800.411C 41.1-动力输出轴总成 41.1-PTO SHAFT ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800A.41.143 动力输出轴连接螺栓 PTO SHAFT CONNECTING BOLT 6 2011-11_

2 FT800A.41C.107 Ⅰ35型动力输出轴 TYPE-I 35 PTO SHAFT 1 2011-11_
3 FT800A.41.144 锁片 LOCK SHIM 3 2011-11_
4 GBT6176-M14X1.5-A3L 2型六角螺母 HEXAGON NUT, TYPE-2 6 2011-11_

234
 TD824-1F161F23K拖拉机

235
 TD824-1F161F23K拖拉机

TD800.412A-1 41.2.1-动力输出齿轮总成-1 PTO GEAR ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M10X40-A3L 螺栓 BOLT 4 2008-06_

1 GBT5783-M10X45-8.8-A3L 六角头螺栓 BOLT 4 2010-12_
10 GBT894.1-45 挡圈 RETAINER RING 1 2011-11_
11 GBT895.2-30 挡圈 RETAINER RING 1 2011-11_
12 FT800.41.105 动力输出传动轴 PTO TRANSMISSION SHAFT 1 2011-11_

13 GBT893.1-28 挡圈 RETAINER RING 1 2011-11_

14 FT800.37.106 动力输出轴连接套 PTO SHAFT CONNECTING SLEEVE 1 2011-11_
2 GBT93-10-A0P 标准型弹簧垫圈 WASHER 4 2011-11_
3 FT800A.41.117 双联齿轮轴承座压盖 DUAL GEAR BEARING SEAT PRESS COVER 1 2011-11_
4 GBT812-M48X1.5-A3L 圆螺母 ROUND NUT 2 2004-01_

5 GBT858-48 圆螺母用止动垫圈 THRUST RING 1 2011-11_

6 GBT297-30210 圆锥滚子轴承 BEARING 2 2011-11_
7 FT800A.41.116 动力输出双联齿轮后轴承座 REAR BEARING SEAT OF PTO DUAL GEAR 1 2011-11_
8 FT800A.41A.101 动力输出低高档主动双联齿轮 PTO LOW AND HIGH GEAR MAIN DRIVING 1 2011-11_
9 GBT276-6309 深沟球轴承 TWIN GEAR 1 2011-11_
BEARING

236
 TD824-1F161F23K拖拉机

237
 TD824-1F161F23K拖拉机

TD800.412A-2 41.2.2-动力输出齿轮总成-2 PTO GEAR ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800A.41.139 动力输出传动轴锁紧螺母 PTO TRANSMISSION SHAFT LOCKNUT 1 2011-11_

10 FT800A.41.102 动力输出高档被动齿轮 PTO HIGH GEAR DRIVEN GEAR 1 2011-11_
11 FT800A.41.142 动力输出传动轴后挡圈 REAR CIRCLIP OF PTO TRANSMISSION SHAFT 1 2011-11_
12 GBT899-AM14-M14X1.5X65-A3L 双头螺柱 8.8-A3L STUD 4 2011-11_
12 GBT899-AM14-M14X1.5X65-A3L 双头螺柱 8.8-A3L STUD 4 2011-11_

13 GBT93-14-A0P 弹簧垫圈 SPRING WASHER 4 2011-11_

13 GBT93-14-A0P 弹簧垫圈 SPRING WASHER 4 2011-11_
14 GBT6176-M14X1.5-A3L 2型六角螺母 HEXAGON NUT, TYPE-2 4 2011-11_
15 GBT297-30212 圆锥滚子轴承 BEARING 2 2011-11_
16 FT800A.41.124 动力输出传动轴后轴承座 REAR BEARING SEAT OF PTO TRANSMISSION 1 2011-11_
SHAFT
17 FT800A.41.152 调整垫片 999 2011-11_
18 FT800A.41.153 挡圈 ADJUSTING WASHER 1 2004-01_
19 GBT9877.1-FB70X90X10D 内包骨架旋转轴唇形密封 RETAINER RING 2 2011-11_
2 FT800A.41.140 动力输出传动轴前挡圈 O RING 1 2011-11_
20 FT800A.41.125 动力输出传动轴后油封座 FRONT CIRCLIP OF PTO TRANSMISSION SHAFT 1 2011-11_
REAR OIL SEAL SEAT OF PTO TRANSMISSION
21 FT800A.41.108 动力输出传动轴 SHAFT 1 2011-11_
3 GBT276-6210 深沟球轴承 1 2011-11_
4 FT800A.41.141 动力输出传动轴中间挡圈 PTO TRANSMISSION SHAFT 1 2011-11_
4 FT800A.41.141 动力输出传动轴中间挡圈 BEARING 1 2011-11_
5 FT800A.41A.104 动力输出低档被动齿轮 MIDDLE CIRCLIP OF PTO TRANSMISSION SHAFT 1 2011-11_
MIDDLE CIRCLIP OF PTO TRANSMISSION SHAFT
6 QSFZB019-K68X78X34 滚动轴承 PTO LOW GEAR DRIVEN GEAR 2 2011-11_
7 FT800A.41.113 动力输出高档齿轮滑套 2 2011-11_
8 FT800.37.118 Ⅲ-Ⅳ档啮合套 ROLLING BEARING 1 2011-11_
9 FT800.37.119 Ⅲ-Ⅳ档啮合齿座 PTO HIGH GEAR SLIDING SLEEVE 1 2011-11_
Ⅲ-Ⅳ SHIFT COLLAR

238
 TD824-1F161F23K拖拉机

239
 TD824-1F161F23K拖拉机

TD800.413 41.3-动力输出操纵机构总成 41.3-PTO CONTROL MECHANISM ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800A.41.147 动力输出操纵杆 PTO CONTROL ROD 1 2011-11_

1.1 FT800A.41.013 动力输出操纵杆总成 PTO CONTROL ROD ASSEMBLY 1 2011-11_
1.2 GBT6170-M10-A2L 螺母 NUT 2 2004-01_
1.3 FT65.38.051 拉压手柄 PULL/PRESS HANDLE 1 2011-11_
1.4 FT804.42.150 拉杆前叉 PULL ROD FRONT FORK 1 2011-11_

1.5 GBT97.1-8-A0P 平垫圈 WASHER 1 2004-01_

1.6 GBT91-3X20-A0P 开口销 PIN 1 2013-07_
1.7 GBT882-B8X26-A2L 销轴 PIN 1 2004-01_
1.8 FT800A.41.146 动力输出摇臂 PTO ROCKER 1 2013-07_
10 GBT879.1-8X35 弹性圆柱销 PIN 1

11 GBT879.1-5X35 弹性圆柱销 PIN 1 2011-11_

12 FT800.37.194 紧定螺钉 LOCKING SCREW 2 2011-11_
13 FT800A.41.241 热镀锌钢丝 ZINC-COATED STEEL WIRE 2 2011-11_
14 FT800.41.240 拨头 FORK HEAD 1 2011-11_
15 GBT6172.1-M16-A3L 螺母 NUT 1 2011-11_

16 TD800.41-03 锥端紧定螺钉 TAPER LOCKING SCREW 1 2011-11_

17 FT800.41.246 锁定销弹簧 LOCKING PIN SPRING 1 2011-11_
17 FT800.41.246 锁定销弹簧 LOCKING PIN SPRING 1 2011-11_
18 FT800.41.245 锁定销 LOCKING PIN 1 2011-11_
19 FT800.41.106a 拨插轴 FORK SHAFT 1 2010-05_

19 FT800.41.106 拨叉轴 FORK SHAFT 1

2 GBT818-M6X16-A2L 十字槽盘头螺钉 SCREW 2 2004-01_
20 FT800A.41.114 动力输出高低档拨叉 PTO HIGH AND LOW GEAR FORK 1 2011-11_
3 FT800A.41.173 密封衬座 SEAL LINER SEAT 1 2011-11_
4 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 2 2004-01_

240
 TD824-1F161F23K拖拉机

241
 TD824-1F161F23K拖拉机

TD800.413 41.3-动力输出操纵机构总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

5 GBT6170-M6-A2L 螺母 NUT 2 2004-01_

6 TD800.41-04 紧定螺钉 LOCKING SCREW 1 2011-11_
7 GBT6170-M12-A3L 螺母 NUT 1
8 GBT3452.1-17X1.8G 液压气动用O形橡胶密封圈 O-SEAL RING 1
9 FT800.41.011 动力输出操纵内摇臂总成 PTO CONTROL INNER ROCKER ASSEMBLY 1 2011-11_

242
 TD824-1F161F23K拖拉机

243
 TD824-1F161F23K拖拉机

TD800.414B 41.4-动力输出防护罩总成 41.4-PTO BONNET INSTALLATION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TD800.411A-02 动力输出轴头护罩 PTO SHAFT HOOD SHIELD 1 2011-11_

2 GBT97.1-5-A0P 垫圈 WASHER 2 2011-11_
3 GBT93-5-A0P 标准型弹簧垫圈 WASHER 2 2011-11_
4 GBT65-M5X12-A2L 开槽圆柱头螺钉 SCREW 2 2011-11_
5 FT800A.41.016 防护罩焊合 SHIELD WELDMENT 1 2011-11_

244
 TD824-1F161F23K拖拉机

245
 TD824-1F161F23K拖拉机

FT804A.42.001-1 42.1-分动箱总成-1 TRANSFER CASE ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT93-10 垫圈10 WASHER 10 6 2011-11_

10 FT804.42.125a 中间传动轴 MIDDLE TRANSMISSION SHAFT 1
10 FT804.42.125b 中间传动轴 MIDDLE TRANSMISSION SHAFT 1 2008-12_
3 FT804A.42.016 外护套焊合（二） OUTER SLEEVE WELDMENT (2) 1 2011-11_
4 GBT894.1-38 轴用弹性挡圈 SNAP RING 4 2011-11_

5 FT804.42.131 隔套 SPACER BUSH 1 2011-11_

6 FT804.42.123a 花键套 SPLINE BUSH 1
6 FT804.42.123b 花键套 SPLINE BUSH 1 2008-12_
7 FT804A.42.130a 前传动轴 FRONT TRANSMISSION SHAFT 1 2008-12_
7 FT804A.42.130 前传动轴 FRONT TRANSMISSION SHAFT 1

8 GBT3452.1-45X3.55G 液压气动用O形橡胶密封圈 O-SEAL RING 2 2011-11_

9 FT804.42.015 内护套焊合（二） INNER SLEEVE WELDMENT (2) 1 2011-11_

246
 TD824-1F161F23K拖拉机

247
 TD824-1F161F23K拖拉机

FT804A.42.001-2 42.2-分动箱总成-2 TRANSFER CASE ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT1152-M10X1 油杯 OIL CUP 1 2011-11_

10 GBT5783-M10X25-A3L 螺栓 BOLT 4 2011-11_
11 GBT93-10-AOP 标准型弹簧垫圈 WASHER 12 2011-11_
12 GBT5781-M10X30-A3L 六角头螺栓 BOLT 8 2011-11_
13 FT804.42.014 内护套焊合（一） INNER SLEEVE WELDMENT (1) 1 2011-11_

14 GBT3452.1-45X3.55G 液压气动用O形橡胶密封圈 O-SEAL RING 2 2011-11_

15 FT804.42.011 外护套焊合（一） OUTER SLEEVE WELDMENT (1) 1 2011-11_
15 FT804.42.011 外护套焊合（一） OUTER SLEEVE WELDMENT (1) 1 2011-11_
16 GBT894.1-30 挡圈 RETAINER RING 2 2011-11_
17 FT804.42.123a 花键套 SPLINE BUSH 1

17 FT804.42.123b 花键套 SPLINE BUSH 1 2008-12_

18 FT804.42.120 前盖 FRONT COVER 1 2011-11_
19 GBT276-6306 深沟球轴承 BEARING 1 2011-11_
2 FT804A.42.129 支承座 SUPPORTING SEAT 1 2011-11_
3 FT804A.42.016 外护套焊合（二） OUTER SLEEVE WELDMENT (2) 2 2011-11_

4 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 2 2011-11_

5 GBT6176-M16X1.5 2型六角螺母 HEXAGON NUT, TYPE-2 2 2011-11_
6 GBT9877.1-FB30X52X7D 内包骨架旋转轴唇形密封 O RING 4 2011-11_
7 FT804.42.128 橡胶圈 RUBBER RING 1 2011-11_
8 GBT276-6006 轴承 BEARING 1 2011-11_

9 FT804.42.127 支承座盖 SUPPORT SEAT COVER 1 2011-11_

248
 TD824-1F161F23K拖拉机

249
 TD824-1F161F23K拖拉机

FT804A.42.001-3 42.3-分动箱总成-3 42TRANSFER CASE ASSEMBLY -3

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT804.42.109 调整垫片 ADJUSTING WASHER 999 2011-11_

10 FT804.42B.161a 垫圈 WASHER 1 2011-11_
11 FT804.42.103a 中间齿轮 MIDDLE GEAR 1 2011-11_
12 FT804.42.105a 分动箱体 TRANSFER CASE BODY 1 2011-11_
13 GBT119.1-8h8X15 圆柱销 PIN 2 2011-11_

14 GBT93-14 垫圈 WASHER 4 2011-11_

14 GBT93-14 垫圈 WASHER 4 2011-11_
15 GBT5781-M14X35-A3L 六角头螺栓 BOLT 4 2011-11_
16 JBT982-18 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_
16 JBT982-18 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_

17 FT804.42.110 螺堵 SCREW PLUG 1 2011-11_

18 FT804.42.118a 分动箱齿轮轴 TRANSFER CASE GEAR SHAFT 1 2011-11_
19 FT804.42.117c 齿轮衬套 GEAR BUSH 1 2011-11_
2 FT804.42.101 隔套 SPACER BUSH 1 2011-11_
20 FT804.42.119a 隔套 SPACER BUSH 1 2011-11_

21 FT804.42.116a 被动齿轮 DRIVEN GEAR 1 2011-11_

22 FT804.42.114 啮合套 SHIFT COLLAR 1 2011-11_
23 FT804.42.115 啮合齿座 MESH GEAR SEAT 1 2011-11_
24 GBT894.1-38 轴用弹性挡圈 SNAP RING 1 2011-11_
25 GBT276-6306 深沟球轴承 BEARING 1 2011-11_

26 FT804.42.112 后盖 COVER REAR 1 2011-11_

27 GBT93-10-AOP 标准型弹簧垫圈 WASHER 4 2011-11_
28 GBT5781-M10X25-A3L 六角头螺栓 BOLT 4 2011-11_
3 FT804.42.102a 主动齿轮 DRIVING GEAR 1 2011-11_
4 FT804.42.111 隔套 SPACER BUSH 1 2011-11_

250
 TD824-1F161F23K拖拉机

251
 TD824-1F161F23K拖拉机

FT804A.42.001-3 42.3-分动箱总成-3(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

5 GBT75-M10X25-A3L 开槽长圆柱端紧定螺钉 SCREW 1 2011-11_

6 GBT6170-M10 螺母M10 NUT M10 1 2011-11_
7 FT804.42.104a 中间齿轮轴 MIDDLE GEAR SHAFT 1 2011-11_
7 FT804.42.104a 中间齿轮轴 MIDDLE GEAR SHAFT 1 2011-11_
8 GBT283-NJ305E 圆柱滚子轴承 BEARING 2 2011-11_

8 GBT283-NJ305E 圆柱滚子轴承 BEARING 2 2011-11_

9 GBT893.1-62 孔用挡圈62 BLOCKING RING - HOLE 1 2011-11_

252
 TD824-1F161F23K拖拉机

253
 TD824-1F161F23K拖拉机

FT804A.42.001-4 42.4-分动箱总成-4 TRANSFER CASE ASSEMBLY-4

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT804.42.110 螺堵 SCREW PLUG 1 2011-11_

10 GBT6170-M10 螺母M10 NUT M10 2 2011-11_
11 FT804A.42.121 导向管 GUIDE PIPE 1 2011-11_
11 FT804A.42.121 导向管 GUIDE PIPE 1 2011-11_
12 FT804A.42.122 操纵杆 CONTROL ROD 1 2011-11_

13 GBT5781-M10X25-A3L 六角头螺栓 BOLT 2 2011-11_

14 GBT93-10-AOP 标准型弹簧垫圈 WASHER 2 2011-11_
15 FT804.42.150 拉杆前叉 PULL ROD FRONT FORK 1 2011-11_
16 GBT882-B8X26 销轴 PIN 1 2011-11_
17 FT804A.42.012 摇臂焊合 ROCKER WELDMENT 1 2011-11_

18 GBT97.1-8-A0P 平垫圈 WASHER 1 2011-11_

19 GBT882-3.2X20 销轴 PIN 1 2011-11_
2 JBT982-18 组合密封垫圈 COMBINED SEAL GASKET 1 2011-11_
2 JBT982-18 组合密封垫圈 COMBINED SEAL GASKET 1 2011-11_
20 GBT879.1-8X30 弹性圆柱销 PIN 1 2011-11_

21 FT804.42.106 侧盖 SIDE COVER 1 2011-11_

22 GBT3452.1-17X1.8G 液压气动用O形橡胶密封圈 O-SEAL RING 2 2011-11_
23 FT804.42.010 转轴焊合 ROTARY SHAFT WELDMENT 1 2011-11_
3 GBT3081-Ⅰ-1.4X100 热镀锌钢丝 ZINC-COATED STEEL WIRE 1 2011-11_
4 FT800.37.194 紧定螺钉 LOCKING SCREW 1 2011-11_

5 FT804.42.107 分离拨叉 RELEASE SHIFT FORK 1 2011-11_

6 FT804.42.108 拨叉轴 FORK SHAFT 1 2011-11_
7 GBT308-10-G100-b 钢球 BALL 1 2011-11_
8 FT804.42.151 弹簧 SPRING 1 2011-11_
9 FT65.38.051 拉压手柄 PULL/PRESS HANDLE 1 2011-11_

254
 TD824-1F161F23K拖拉机

255
 TD824-1F161F23K拖拉机

FT800A.43C.001 43-制动系总成 43-BRAKE SYSTEM ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 FT800A.43C.001-1 43.1-制动系总成-1 43BRAKING SYSTEM ASSEMBLY-1 0 2011-11_

0 FT800A.43C.001-2 43.2-制动系总成-2 43BRAKING SYSTEM ASSEMBLY-2 0 2011-11_
0 FT800A.43C.001-3 43.3-制动系总成-3 43BRAKING SYSTEM ASSEMBLY-3 0 2011-11_
0 FT800A.43C.001-5 43.5-制动系总成-5 43BRAKING SYSTEM ASSEMBLY-5 0 2011-11_
0 FT800A.43C.001-6 43.6-制动系总成-6 43BRAKING SYSTEM ASSEMBLY-6 0 2011-11_

0 FT800A.43C.001-7 43.7-制动系总成-7 BREAKE SYSTEM ASSEMBLY-7 0 2011-11_

0 FT800A.43C.001-4 43.4-制动系总成-4 43BRAKING SYSTEM ASSEMBLY-4 0 2011-11_
11 GBT6170-M8-A2L 螺母 NUT 1 2011-11_
9 GBT882-B10X30 销轴 PIN 1 2011-11_

256
 TD824-1F161F23K拖拉机

257
 TD824-1F161F23K拖拉机

FT800A.43C.001-1 43.1-制动系总成-1 43BRAKING SYSTEM ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 FT800A.43.014 手制动总成 HANDLE BRAKE ASSEMBLY 1 2011-11_

1 FT800A.43.051 手制动操纵把手总成 HAND BRAKE CONTROLLING HANDLE 1 2011-11_
10 FT800.43.132 盖座 ASSEMBLY 1 2011-11_
11 GBT882-B10X30 销轴 COVER SEAT 1 2011-11_
12 GBT97.1-10-AOP 垫圈 PIN 1 2011-11_
WASHER
13 GBT5781-M10X30-A3L 六角头螺栓 4 2004-01_
14 FT800A.43.321 转柄 BOLT 1 2011-11_
15 GBT879.1-8X30 弹性圆柱销 ROTARY HANDLE 1 2011-11_
16 GBT879.1-5X30 弹性圆柱销 PIN 1 2011-11_
17 GBT93-10 垫圈10 PIN 4 2011-11_
WASHER 10
18 GBT5783-M10X30-A3L 螺栓 4 2011-11_
2 GBT5783-M8X20-A2L 螺栓 BOLT 4 2011-11_
3 GBT93-8 垫圈8 BOLT 4 2011-11_
4 GBT6170-M8-A2L 螺母 WASHER 8 4 2011-11_
5 GBT6171-M10X1-A2L 螺母 NUT 1 2011-11_
NUT
6 FT800.21.240 拉杆前叉 1 2011-11_
7 FT800.43.169 制动凸轮轴 PULL ROD FRONT FORK 1 2011-11_
8 GBT3452.1-15.0X2.65 液压气动用O形橡胶密封圈 BRAKE CAMSHAFT 2 2011-11_
9 GBT882-B10×30 销轴 O-SEAL RING 1 2011-11_
PIN

258
 TD824-1F161F23K拖拉机

259
 TD824-1F161F23K拖拉机

FT800A.43C.001-2 43.2-制动系总成-2 43BRAKING SYSTEM ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 FT800A.43.014 手制动总成 HANDLE BRAKE ASSEMBLY 1 2011-11_

1 FT800.43.194 螺栓 BOLT 2 2011-11_
10 FT800.43.145 调整垫片 ADJUSTING WASHER 999 2011-11_
2 GBT854-10 单耳制动垫圈 WASHER 2 2011-11_
2 GBT854-10 单耳制动垫圈 WASHER 2 2011-11_

3 FT800.43.131 压板 PRESSURE PLATE 1 2011-11_

4 FT800.43.023 磨擦片合件 FRICTION PLATE UNIT 2 2011-11_
5 FT800.43.024 中间磨擦片合件 MIDDLE FRICTION PLATE UNIT 1 2011-11_
6 FT800.43.141 钢片 STEEL PIECE 2 2011-11_
7 GBT894.1-48 挡圈 RETAINER RING 1 2011-11_

8 FT800.43.136 花键套轮 SPLINE BUSH WHEEL 1 2011-11_

9 FT800.43.142 调整垫片 ADJUSTING WASHER 999 2011-11_

260
 TD824-1F161F23K拖拉机

261
 TD824-1F161F23K拖拉机

FT800A.43C.001-3 43.3-制动系总成-3 43BRAKING SYSTEM ASSEMBLY-3

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 FT800A.43.051 手制动操纵把手总成 HAND BRAKE CONTROLLING HANDLE 1 2011-11_

0 FT800A.43.014 手制动总成 ASSEMBLY 1 2011-11_
1 FT800A.21.045 按钮总成 HANDLE BRAKE ASSEMBLY 1 2011-11_
10 GBT894.1-6 轴用弹性挡圈 BUTTON ASSEMBLY 1 2011-11_
11 FT800A.21.323 销 SNAP RING 1 2011-11_
PIN
12 FT800A.43.070 手制动短拉杆焊合 1 2011-11_
13 GBT6171-M10X1-A2L 螺母 PULL ROD WELDMENT 1 2011-11_
14 TG1204.435-01 调节套筒 NUT 1 2011-11_
15 FT800A.43.403 手制动长拉杆 ADJUSTING SLEEVE 1 2011-11_
16 GBT894.1-13 轴用弹性挡圈 HANDLE BRAKE LONG PULL ROD 2 2011-11_
SNAP RING
17 FT800A.43.058 手制动操纵把手固定座焊合 1 2011-11_
18 FT800A.21.321 销轴 HANDLE FIXING SEAT WELDMENT OF HAND 1 2011-11_
19 FT800A.43.310 棘轮 BRAKE 1 2011-11_
2 FT800A.21.319 操纵把手套 PIN 1 2011-11_
3 FT800.43.180 弹簧 RATCHET WHEEL 1 2011-11_
CONTROLLING HANDLE SLEEVE
4 FT800A.21.315 顶杆 SPRING 1 2011-11_
5 FT800A.21.320 护罩 1 2011-11_
6 GBT68-M4X10-A2L 开槽双头螺钉 TOP ROD 4 2011-11_
7 FT800A.21.322 小销轴 BONNET 1 2011-11_
8 FT800A.21.044 操纵把手总成 1 2011-11_
SMALL PIN SHAFT
9 FT800A.21.314 棘爪 CONTROLLING HANDLE ASSEMBLY 1 2011-11_

PAWL

262
 TD824-1F161F23K拖拉机

263
 TD824-1F161F23K拖拉机

FT800A.43C.001-4 43.4-制动系总成-4 43BRAKING SYSTEM ASSEMBLY-4

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 FT800.43.015 制动器总成 BREAK ASS. 1 2011-11_

1 FT800.43.149 O形密封环 O-SEAL RING 2 2011-11_
10 FT800.43.173 弹簧 SPRING 6 2011-11_
11 GBT879.1-5X16 弹性圆柱销 PIN 1
12 FT800.43.150 O形密封环 O-SEAL RING 2 2011-11_

13 FT800.43.151 制动器活塞 BRAKE PISTON 2 2011-11_

14 FT800.43.027 磨擦片组合件 FRICTION PLATE UNIT 2 2011-11_
15 FT800.43.147 左制动器缸体 LEFT BRAKE CYLINDER HOUSING 1 2004-01_
15 FT800.43.147B 左制动气缸体 LEFT BRAKE CYLINDER HOUSING 1 2011-01_
15 FT800.43.147 左制动器缸体 LEFT BRAKE CYLINDER HOUSING 1 2004-01_

2 FT800.43.153 右制动器缸体 RIGHT BRAKE CYLINDER 1 2004-01_

2 FT800.43.153 右制动器缸体 RIGHT BRAKE CYLINDER 1 2004-01_
2 FT800.43.153B 右制动气缸体 RIGHT BRAKE CYLINDER 1 2011-01_
3 FT800.43.152 放气螺塞 DISCHARGE AIR PLUG 2 2011-11_
4 FT800.43.156 防尘圈 2 2011-11_

5 JBT982-16 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_

6 FT800.43.130 接头体 JOINT BODY 2 2011-11_
7 GBT3452.1-10.0X1.80G 液压气动用O形橡胶密封圈 O-SEAL RING 2 2011-11_
8 JBT982-10 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_
8 JBT982-10 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_

9 TG1204.431-08 六角头螺塞 SCREW PLUG 2 2011-11_

264
 TD824-1F161F23K拖拉机

265
 TD824-1F161F23K拖拉机

FT800A.43C.001-5 43.5-制动系总成-5 43BRAKING SYSTEM ASSEMBLY-5

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.21.215 副离合回位弹簧 AUXILIARY CLUTCH RETURN SPRING 2

1 TD800.43-01 踏板回位弹簧 PEDAL RETURN SPRING 2 2010-03_
10 FT800A.43.401 锁销 PIN 1 2011-11_
11 FT800.43.030 调整螺钉 ADJUSTING SCREW 2 2011-11_
2 FT800.43.103 调整螺钉 ADJUSTING SCREW 2 2011-11_

3 GBT5783-M8X20-A2L 螺栓 BOLT 1 2011-11_

4 GBT93-8-A0P 垫圈 WASHER 1 2011-11_
5 FT800A.43.053 制动踏板支承轴焊合 BRAKE PEDAL SUPPORT SHAFT WELDMENT 1 2011-11_
6 FT800A.43C.014 右制动摇臂合件 RIGHT BRAKE ROCKER UNIT 1 2011-11_
6.1 FT800A.43.307 制动踏板毂衬套 BRAKE PEDAL HUB BUSH 2 2011-11_

6.2 FT800A.43C.016 右制动摇臂焊合 RIGHT BRAKE ROCKER WELDMENT 1 2011-11_

6.3 GBT879.1-5X16 弹性圆柱销 PIN 1 2011-11_
6.4 FT800A.43.065 制动联锁杆焊合 BRAKE CONNECTING LOCK ROD WELDMENT 1 2011-11_
7 GBT6170-M10-A3L 螺母 NUT 4 2011-11_
8 FT800A.43C.013 左制动摇臂合件 LEFT BRAKE ROCKER WELDMENT 1 2011-11_

8.1 FT800A.43.307 制动踏板毂衬套 BRAKE PEDAL HUB BUSH 2 2011-11_

8.2 FT800A.43C.015 左制动摇臂焊合 LEFT BRAKE ROCKER WELDMENT 1 2011-11_
9 GBT894.1-30 挡圈 RETAINER RING 1 2011-11_

266
 TD824-1F161F23K拖拉机

267
 TD824-1F161F23K拖拉机

FT800A.43C.001-6 43.6-制动系总成-6 43BRAKING SYSTEM ASSEMBLY-6

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.43.018 制动油箱 BRAKE OIL TANK 1 2004-01_

1 TG1204.433.2 制动器油箱总成 BRAKE OIL TANK ASSEMBLY 1 2010-04_
10 FT800A.43C.018 制动泵总成 BRAKE PUMP ASSEMBLY 1 2011-11_
11 GBT97.1-10-A0P 平垫圈 WASHER 3 2011-11_
12 GBT5783-M10X30-A3L 螺栓 BOLT 3 2011-11_

2 GBT5783-M10X20-A3L 螺栓 BOLT 2 2011-11_

3 GBT93-10-A0P 标准型弹簧垫圈 WASHER 5 2011-11_
4 TD800.43.2 制动油箱支架焊合 BRAKE OIL TANK BRACKET WELDMENT 1 2011-11_
5 TG1204.433-04 卡环 CLAMP RING 2 2011-11_
6 Q67516 A型蜗杆传动式软管环箍 A-TYPE WORM TRANSMISSION HOSE CLAMP 2 2011-11_

7 FT800A.43C.105 输油软管 OIL CONVEYING HOSE 2 2011-11_

8 FT800.43.115 油管接头螺钉 OIL PIPE JOINT SCREW 2 2011-11_
9 JBT982-12 组合密封垫圈 COMBINED SEAL GASKET 4 2011-11_

268
 TD824-1F161F23K拖拉机

269
 TD824-1F161F23K拖拉机

FT800A.43C.001-7 43.7-制动系总成-7 BREAKE SYSTEM ASSEMBLY-7

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.43.115 油管接头螺钉 OIL PIPE JOINT SCREW 4 2011-11_

10 F600190 管夹组合（五） PIPE CLAMP COMBINATION（5） 2 2011-11_
11 FT800A.43.335 油管固定板 FIXED PLATE OF OIL PIPE 2 2011-11_
2 JBT982-12 组合密封垫圈 COMBINED SEAL GASKET 8 2011-11_
3 FT800A.43C.011a 左制动短油管总成 LEFT BRAKE SHORT OIL PIPE ASSEMBLY 1 2004-01_

3 FT800A.43C.011b 左制动短油管总成 LEFT BRAKE SHORT OIL PIPE ASSEMBLY 1 2011-01_

4 FT800A.43C.012a 右制动短油管总成 RIGHT BRAKE SHORT OIL PIPE ASSEMBLY 1 2004-01_
4 FT800A.43C.012b 右制动短油管总成 RIGHT BRAKE SHORT OIL PIPE ASSEMBLY 1 2011-01_
5 FT800A.43C.017 管接头焊合件 PIPE JOINT WELDMENT UNIT 2 2011-11_
6 FT800A.43.315 卡套式直通接头体 JOINT 2 2011-11_

7 FT800A.43.057b 右制动长油管总成 RIGHT BRAKE LONG OIL PIPE ASSEMBLY 1 2011-01_

7 FT800A.43.057a 右制动长油管总成 RIGHT BRAKE LONG OIL PIPE ASSEMBLY 1 2004-01_
8 FT800A.43.056b 左制动长油管总成 LEFT BRAKE LONG OIL PIPE ASSEMBLY 1 2011-01_
8 FT800A.43.056b 左制动长油管总成 LEFT BRAKE LONG OIL PIPE ASSEMBLY 1 2011-01_
8 FT800A.43.056a 左制动长油管总成 LEFT BRAKE LONG OIL PIPE ASSEMBLY 1 2004-01_

9 F600210 管夹组合（六） PIPE CLAMP COMBINATION（6） 2 2011-11_

270
 TD824-1F161F23K拖拉机

271
 TD824-1F161F23K拖拉机

FT800A.44.001 44-座椅安装总成 44SEAT INSTALLATION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800A.44.011 座椅总成 SEAT ASSEMBLY 1 2011-11_

2 GBT5783-M12X35-A3L 螺栓 BOLT 4 2011-11_
2 GBT5783-M12X35-A3L 螺栓 BOLT 4 2011-11_
3 GBT93-12-A0P 弹簧垫圈 SPRING WASHER 4 2011-11_
4 GBT97.1-12-A0P 平垫圈 WASHER 4 2011-11_

272
 TD824-1F161F23K拖拉机

273
 TD824-1F161F23K拖拉机

TD800.452J-1 45.2.1-地板总成-1 FLOOR ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TD800.452C.2 后地板焊合 REAR FLOOR WELDMENT 1 2011-11_

10 TD800.452I.1 前地板焊合 FRONT FLOOR WELDMENT 1 2011-11_
11 GBT5782-M12X120-A2L 六角头螺栓 BOLT 4 2011-11_
12 GBT5782-M12x60-A2L 螺栓 BOLT 6 2011-11_
13 GBT96-12-A0P 大垫圈 WASHER 10 2011-11_

14 GBT93-12-A0P 弹簧垫圈 SPRING WASHER 10 2011-11_

15 GBT6170-M12-A3L 螺母 NUT 10 2011-11_
16 TD800.452-04 堵盖 PLUG COVER 1 2011-11_
17 FT65.45B.733 前下窗密封条 FRONT LOWER WINDOW SEAL STRIP 2 2011-11_
18 FT65.45B.732 前下窗玻璃 FRONT LOWER WINDOW GLASS 2 2004-01_

19 TD800.452N.1 脚蹬安装总成 PEDAL INSTALLATION ASSEMBLY 2 2011-11_

19.1 TD800.452N.1.1 脚蹬焊合 PEDAL WELDMENT 2 2011-11_
19.2 GBT97.1-10-AOP 垫圈 WASHER 6 2011-11_
19.3 GBT93-10-AOP 标准型弹簧垫圈 WASHER 6 2011-11_
19.4 GBT5783-M10X35-A2L 六角头螺栓 BOLT 6 2011-11_

2 FT65.45B.073 后护围总成 REAR PLATE ASSEMBLY 1 2011-11_

2.1 FT65.45B.729 前围上弯梁 FRONT WALL UPPER BENDING BEAM 1 2011-11_
2.2 FT65.45B.738 连接螺纹头 CONNECTING THREAD HEAD 1 2011-11_
2.3 GBT97.1-16-A0P 垫圈 WASHER 2 2011-11_
2.4 GBT96-16-A0P 大垫圈 WASHER 2 2011-11_

2.5 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 2 2011-11_

2.6 GBT6170-M16-A2L 螺母 NUT 2 2011-11_
20 FT65.45.393 油门踏板密封套 THROTTLE PEDAL SEAL SLEEVE 1 2011-11_
21 FT65.45.394 油门踏板密封套压板 THROTTLE PEDAL SEAL SLEEVE PRESSURE 1 2011-11_
22 GBT5783-M5X12-A2L 六角头螺栓 PLATE 3 2011-11_

274
 TD824-1F161F23K拖拉机

275
 TD824-1F161F23K拖拉机

TD800.452J-1 45.2.1-地板总成-1(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

23 GBT93-5-A0P 标准型弹簧垫圈 WASHER 3 2011-11_

24 TD800.452J-01 地板垫 FLOOR MAT 1 2011-11_
3 GBT68-M6X12-A2L 开槽沉头螺钉 SCREW 6 2011-11_
4 TD800.452A-01 盖板 COVER PLATE 1 2011-11_
5 GBT5783-M6X20-A2L 螺栓 BOLT 4 2011-11_

6 FT800A.45.160 支撑板 SUPPORTING BOARD 1 2011-11_

7 GBT97.1-6-A0P 平垫圈 WASHER 4 2011-11_
8 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 4 2011-11_
9 GBT6170-M6-A2L 螺母 NUT 4 2011-11_

276
 TD824-1F161F23K拖拉机

277
 TD824-1F161F23K拖拉机

TD800.452J-2 45.2.2-地板总成-2 FLOOR ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M6X20-A2L 螺栓 BOLT 6 2011-11_

10 GBT97.1-4-A0P 垫圈 WASHER 4 2011-11_
11 TD800.452-09 密封套 SEAL SLEEVE 1 2011-11_
2 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 6 2011-11_
3 GBT97.1-6-A0P 平垫圈 WASHER 6 2011-11_

4 FT800A.45.031 封板焊合 SEAL PLATE WELDMENT 1 2011-11_

5 TD800.452-02 后下窗玻璃密封条 REAR LOWER WINDOW GLASS SEAL STRIP 1 2011-11_
6 TD800.452-01 后下窗玻璃 REAR LOWER WINDOW GLASS 1 2011-11_
7 TD800.452-14 前堵板 FRONT BLOCK PLATE 1 2011-02_
7 FT65.45C.351 前堵板 FRONT BLOCK PLATE 1 2004-01_

8 GBT5783-M4X12-A2L 六角头螺栓 BOLT 4 2011-11_

9 GBT93-4-A0P 标准型弹簧垫圈 WASHER 4 2011-11_

278
 TD824-1F161F23K拖拉机

279
 TD824-1F161F23K拖拉机

TD800.454A 45.4-操纵盖板总成 45.4-CONTROLLING COVER PLATE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT804A.45.097 盖板组合 COVER PLATE COMBINATION 1 2011-11_

2 FT65.45.101 风扇 FAN 4 2011-11_
3 GBT93-5-AOP 标准型弹簧垫圈 WASHER 4 2011-11_
4 GBT97.1-5-A0P 垫圈 WASHER 4 2011-11_
5 FT804A.45.315 中地板垫 MIDDLE FLOOR MAT 1 2011-11_

280
 TD824-1F161F23K拖拉机

281
 TD824-1F161F23K拖拉机

TD800.456A 45.6-仪表台装配总成 45.6-DASHBOARD INSTALLATION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800A.45B.020 仪表台总成 DASHBOARD ASSEMBLY 1 2011-11_

2 FT65.45.999 1型六角螺母 NUT 2 2011-11_
3 GBT901-M6X60-A1L 等长双头螺柱 STUD 2 2011-11_
4 FT800A.45.900 塑料螺钉 PLASTIC SCREW 6 2004-01_
4 GBT818 螺钉M4x16 SCREW M4X16 6 2010-06_

282
 TD824-1F161F23K拖拉机

283
 TD824-1F161F23K拖拉机

TD800.457 45.7-前连接装置总成 45.7-FRONT CONNECTION EQUIPMENT ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TD800.457-01 前连接板 FRONT CONNECTING PLATE 2 2011-11_

2 FT800A.45.112 减震垫座 SHOCK ABSORBER SEAT 8 2011-11_
3 FT800A.45.110 减震块 ABSORBER 8 2011-11_
4 FT800A.45.111 间管 SPACER SPOOL 4 2011-11_
5 GBT96-16-A0P 大垫圈 WASHER 4 2011-11_

6 GBT5782-M16X130-A2L 六角头螺栓 BOLT 4 2011-11_

7 GBT5783-M16X45 螺栓 BOLT 8
8 GBT97.1-16-A0P 垫圈 WASHER 8 2011-11_
9 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 8 2011-11_

284
 TD824-1F161F23K拖拉机

285
 TD824-1F161F23K拖拉机

TD800.458A 45.8-后连接装置总成 45.8--REAR CONNECTING EQUIPMENT ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5782-M16X160-A2L 六角头螺栓 BOLT 4 2011-11_

10 GBT6170-M16-A3L 螺母 M16-A3L NUT 8 2011-11_
2 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 8 2011-11_
3 GBT96.1-16-A0P 垫圈16-A0P WASHER 8 2011-11_
4 FT800A.45.112 减震垫座 SHOCK ABSORBER SEAT 8 2011-11_

5 FT800A.45.110 减震块 ABSORBER 8 2004-01_

5 TD800.457B.1.2 减震块 ABSORBER 8 2009-06_
5 TD800.457B.1.2 减震块 ABSORBER 8 2009-06_
6 FT800A.45.111 间管 SPACER SPOOL 4 2011-11_
7 FT800A.45C.014 地板后连接焊合件 FLOOR REAR CONNECTING WELDMENT 2 2011-11_

8 GBT5783-M16X90-8.8-A2L 六角头螺栓 BOLT 4 2004-01_

9 GBT97.1-16-A0P 垫圈 WASHER 4 2011-11_

286
 TD824-1F161F23K拖拉机

287
 TD824-1F161F23K拖拉机

FT800A.46.001 46-安全架总成 46-SAFETY FRAME ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M10X30-A3L 螺栓 BOLT 6 2011-11_

10 GBT802-M12-A2L 螺母 NUT 4
11 FT800A.46.040 支撑梁安装总成 SUPPORT BEAM INSTALLATION ASSEMBLY 1 2011-11_
11 FT800A.46.040 支撑梁安装总成 SUPPORT BEAM INSTALLATION ASSEMBLY 1 2011-11_
11.1 FT800A.46.010 安全架上梁总成 SAFETY FRAME UPPER BEAM ASSEMBLY 1 2011-11_

11.1 FT800A.46.010 安全架上梁总成 SAFETY FRAME UPPER BEAM ASSEMBLY 1 2011-11_

11.2 GBT5782-M16X100-A2L 六角头螺栓 BOLT 6 2011-11_
11.3 GBT95-16-A0P 垫圈 WASHER 6 2011-11_
11.4 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 6 2011-11_
11.5 GBT802-M16 组合式盖形螺母 NUT 6

11.6 FT800A.46.030 右支撑梁总成 RIGHT SUPPORT BEAM ASSEMBLY 1 2011-11_

11.7 FT800A.46.020 左支撑梁总成 LEFT SUPPORT BEAM ASSEMBLY 1 2011-11_
12 GBT5782-M16X90-A2L 六角头螺栓 BOLT 8 2011-11_
13 GBT96-16-A0P 大垫圈 WASHER 8 2011-11_
14 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 8 2011-11_

15 GBT6170-M16-A3L 螺母 M16-A3L NUT 8 2011-11_

2 FT800A.46.101 遮阳棚固定板 SHADOW LOCKING PLATE 2 2011-11_
3 FT400.46.021 垫圈合件 WASHER UNIT 6 2011-11_
4 GBT93-10-A0P 标准型弹簧垫圈 WASHER 6 2011-11_
5 GBT802-M10-6 组合式盖形螺母 NUT 6 2011-11_

6 FT65.46A.012 遮阳棚总成 SHADOW ASSEMBLY 1 2004-01_

6 FT800A.46.480 遮阳棚 SHADOW 1 2011-05_
7 GBT5782-M12x80-A2L 螺栓 BOLT 4 2011-11_
8 GBT95-12-A0P 垫圈12-A0P WASHER 4 2011-11_
9 GBT93-12-A0P 弹簧垫圈 SPRING WASHER 4 2011-11_

288
 TD824-1F161F23K拖拉机

289
 TD824-1F161F23K拖拉机

TD800.471A-1 47.1.1-机罩总成-1 BONNET ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TG1204.471A-05 机罩前脸网眼板 BONNET FRONT MESH BOARD 1 2011-11_

10 FT800B.47.306 左前下栅格 LEFT FRONT LOWER GRID 1 2011-11_
11 FT800B.47.307 右前下栅格 RIGHT FRONT LOWER GRID 1 2011-11_
11 FT800B.47.307 右前下栅格 RIGHT FRONT LOWER GRID 1 2011-11_
12 TG1204.471A-03 机罩左侧网眼板 BONNET LEFT MESH PLATE 1 2011-11_

12 TG1204.471A-03 机罩左侧网眼板 BONNET LEFT MESH PLATE 1 2011-11_

13 TG1204.471A-04 机罩右侧网眼板 BONNET RIGHT MESH PLATE 1 2011-11_
14 TD800.471A-01 机罩气弹簧 BONNET PNEUMATIC SPRING 2 2011-11_
15 TD800.471A-02 机罩拉绳 BONNET PULL WIRE 1 2011-11_
16 GBT5783-M6X16－A3L 螺栓 BOLT 19 2011-11_

17 GBT97.1-6-A0P 平垫圈 WASHER 20 2011-11_

18 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 20 2011-11_
19 GBT6170-M6-A2L 螺母 NUT 20 2011-11_
2 TD800.471A.1 机罩焊合 BONNET WELDMENT 1 2011-11_
20 TB400B.471-18 垫块 PAD BLOCK 24 2011-11_

21 GBT97.1-5-A0P 垫圈 WASHER 40 2011-11_

22 GBT93-5-A0P 标准型弹簧垫圈 WASHER 40 2011-11_
23 GBT6170-M5-A2L 1型六角螺母 NUT 40 2011-11_
3 FT800B.47.242 机罩密封条 BONNET SEAL STRIP 1 2011-11_
4 FT800B.47.304 左后装饰板 LEFT REAR ADORN BOARD 1 2011-11_

5 FT800B.47.305 右后装饰板 RIGHT REAR ADORN BOARD 1 2011-11_

6 FT800B.47.310 左后下栅格 LEFT REAR LOWER GRID 1 2011-11_
7 FT800B.47.311 右后下栅格 RIGHT REAR LOWER GRID 1 2011-11_
7 FT800B.47.311 右后下栅格 RIGHT REAR LOWER GRID 1 2011-11_
8 FT800B.47.308 左中下栅格 LEFT MIDDLE LOWER GRID 1 2011-11_

290
 TD824-1F161F23K拖拉机

291
 TD824-1F161F23K拖拉机

TD800.471A-1 47.1.1-机罩总成-1(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

9 FT800B.47.309 右中下栅格 RIGHT MIDDLE LOWER GRID 1 2011-11_

292
 TD824-1F161F23K拖拉机

293
 TD824-1F161F23K拖拉机

TD800.471A-2 47.1.2-机罩总成-2 BONNET ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT91-5X32-A0P 开口销 PIN 2 2011-11_

10 GBT97.1-10-A0P 平垫圈 WASHER 3 2011-11_
11 GBT93-10-A0P 标准型弹簧垫圈 WASHER 3 2011-11_
12 GBT5783-M10X45-A3L 螺栓 BOLT 2 2011-11_
13 GBT5783-M10X30-A3L 螺栓 BOLT 1 2011-11_

14 GBT882-B16X90-A0P 销轴 PIN 2 2011-11_

15 GBT5783-M12X30-A3L 螺栓 BOLT 3 2011-11_
16 GBT93-12-A0P 弹簧垫圈 SPRING WASHER 3 2011-11_
17 GBT97.1-12-A0P 平垫圈 WASHER 3 2011-11_
18 GBT6170-M10-A3L 螺母 NUT 2 2011-11_

2 GBT97.1-16-A0P 垫圈 WASHER 2 2011-11_

3 FT800B.47B.162 铰链下座 HINGE LOWER SEAT 1 2011-11_
4 GBT5782-M12X50-A3L 螺栓 BOLT 3 2011-11_
5 FT800B.47.060a 机罩下支架焊合 BONNET LOW BRACKET WELDMENT 1 2011-11_
6 GBT97.1-12-A0P 平垫圈 WASHER 3 2011-11_

7 GBT93-12-A0P 弹簧垫圈 SPRING WASHER 3 2011-11_

8 GBT6170-M12-A3L 螺母 NUT 3 2011-11_
9 FT800B.47B.161 铰链上座 HINGE UPPER SEAT 2 2011-11_

294
 TD824-1F161F23K拖拉机

295
 TD824-1F161F23K拖拉机

TD800.472B 47.2-机罩下围板总成 47.2-BONNET LOW PLATE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800B.47.241 机罩下围板密封条 BONNET LOW PLATE SEAL STRIP 1 2011-11_

2 TD800.472B.1 机罩下围板焊合 BONNET LOW PLATE WELDMENT 1 2011-11_
3 GBT5783-M8X25-A2L 螺栓 BOLT 6 2011-11_
4 GBT97.1-8-A0P 平垫圈 WASHER 6 2011-11_
5 GBT93-8-A0P 垫圈 WASHER 6 2011-11_

296
 TD824-1F161F23K拖拉机

297
 TD824-1F161F23K拖拉机

TD800.472A 47.2-机罩下围板总成 47.2-BONNET LOW PLATE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800B.47.241 机罩下围板密封条 BONNET LOW PLATE SEAL STRIP 1 2011-11_

2 GBT5783-M8X25-A2L 螺栓 BOLT 4 2011-11_
3 GBT93-8-A0P 垫圈 WASHER 4 2011-11_
4 GBT97.1-8-A0P 平垫圈 WASHER 4 2011-11_
5 TD800.472A.1 机罩下围板焊合 BONNET LOW PLATE WELDMENT 1 2011-11_

5 TD800.472A.1 机罩下围板焊合 BONNET LOW PLATE WELDMENT 1 2011-11_

298
 TD824-1F161F23K拖拉机

299
 TD824-1F161F23K拖拉机

TD800.474A 47.4-机罩锁操纵总成 47.4-BONNET LOCK CONTROL ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT6170-M6-A2L 螺母 NUT 5 2011-11_

10 GBT97.1-8-A0P 平垫圈 WASHER 3 2011-11_
11 GBT93-8-A0P 垫圈 WASHER 3 2011-11_
12 GBT6170-M8-A2L 螺母 NUT 3 2011-11_
13 GBT894.1-10 轴用弹性挡圈 SNAP RING 1 2011-11_

14 FT800A.47.092 摇臂焊合 ROCKER WELDMENT 1 2011-11_

15 TD800.474A-01 支座 RETAINER 1 2011-11_
16 GBT97.1-14-A0P 垫圈14-A0P WASHER 1 2011-11_
17 FT800A.47.098 拉杆焊合（二） PULL ROD WELDMENT (2) 1 2011-11_
18 FT800A.47.056 手柄总成 HANDLE ASSEMBLY 1 2011-11_

2 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 4 2011-11_

3 GBT97.1-6-A0P 平垫圈 WASHER 7 2011-11_
4 GBT5782-M8X70-A2L 六角头螺栓 BOLT 3 2011-11_
5 GBT818-M6X40-A1L 十字槽盘头螺钉 SCREW 4 2011-11_
6 FT800.47.127 机罩锁总成 BONNET LOCK ASSEMBLY 1 2011-11_

7 GBT91-1.6X10-A0P 开口销 PIN 3

8 TD800.474A-02 机罩锁支架 BONNET LOCK BRACKET 1 2011-11_
9 FT800A.47.096 拉杆焊合（一） PULL ROD WELDMENT (1) 1 2011-11_

300
 TD824-1F161F23K拖拉机

301
 TD824-1F161F23K拖拉机

TD800.474B 47.4-机罩锁操纵总成 47.4-BONNET LOCK CONTROL ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M10X30-A3L 螺栓 BOLT 2 2011-11_

1 GBT5783-M8X30-A3L 六角头螺栓全螺纹 BOLT 2 2009-04_
10 GBT6170-M6-A2L 螺母 NUT 5 2011-11_
11 TD800.474B.2 拉杆焊合 WELDED PUSHING ROD 1 2011-11_
12 TB450.473-02 胶圈 RUBBER RING 1 2011-11_

13 FT800A.47.056 手柄总成 HANDLE ASSEMBLY 1 2011-11_

2 TD800.474B.1 机罩锁柱焊合 BONNET LOCK COLUMN WELDMENT 1 2011-11_
2 TD800.474B.1 机罩锁柱焊合 BONNET LOCK COLUMN WELDMENT 1 2011-11_
3 GBT93-10-A0P 标准型弹簧垫圈 WASHER 2 2011-11_
4 GBT97.1-8-A0P 平垫圈 WASHER 2 2009-04_

4 GBT97.1-10-A0P 平垫圈 WASHER 2 2011-11_

5 GBT5783-M6X35-8.8-A1L 六角头螺栓 BOLT 4
6 TH350.473-01 机罩锁 BONNET LOCK 1
6 TG1654.471A.2.1-01 机罩锁 BONNET LOCK 1 2011-02_
7 GBT97.1-6-A0P 平垫圈 WASHER 5 2011-11_

8 GBT91-1.6X26-A0P 开口销 PIN 1 2011-11_

9 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 4 2011-11_

302
 TD824-1F161F23K拖拉机

303
 TD824-1F161F23K拖拉机

TD800.475C 47.5-机罩密封装配总成 47.5-BONNET SEAL INSTALLATION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT6170-M6-A2L 螺母 NUT 10 2011-11_

2 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 10 2011-11_
3 GBT97.1-6-A0P 平垫圈 WASHER 10 2011-11_
4 TD800.475C-01 水箱密封板 WATER TANK SEAL PLATE 1 2011-11_
4 TD800.475C-01 水箱密封板 WATER TANK SEAL PLATE 1 2011-11_

5 TD800.475B-01 水箱密封块 WATER TANK SEAL BLOCK 1 2011-11_

6 GBT5783-M6X20-A2L 螺栓 BOLT 10 2011-11_
7 TD800.475C-02 密封压条 SEAL PRESSURE STRIP 1 2011-11_
8 TD800.475B-06 密封压条 SEAL PRESSURE STRIP 1 2011-11_
9 TD800.475B-04 密封条 SEAL STRIP 1 2011-11_

304
 TD824-1F161F23K拖拉机

305
 TD824-1F161F23K拖拉机

TD900.481A 48.1-发动机线束安装总成 48.1-ENGINE HARNESS INSTALLATION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.48L.108a 紧固夹 FASTENING CLIP 2 2011-11_

2 GBT97.1-10-A0P 平垫圈 WASHER 2 2011-11_
3 GBT5783-M10X20-A3L 螺栓 BOLT 2 2011-11_
4 TF1004.482-01 过线胶圈 RUBBER RING 1 2011-11_
4 TF1004.482-01 过线胶圈 RUBBER RING 1 2011-11_

5 FT800.48L.107 护线套 SLEEVE 2 2011-11_

6 FT800.48L.106 电线套管 WIRE SLEEVE 1 2011-11_
7 FT800A.48.024 发动机线束总成 ENGINE HARNESS ASSEMBLY 1 2004-01_
7 TD900.481A.1 发动机线束总成 ENGINE HARNESS ASSEMBLY 1 2011-05_
8 FT65.48.074 转速传感器 RPM SENSOR 1 2011-11_

9 FT65.48.073a 机油压力传感器 OIL PRESSURE SENSOR 1 2010-01_

9 FT700.48G.073a 机油压力传感器 OIL PRESSURE SENSOR 1 2004-01_

306
 TD824-1F161F23K拖拉机

307
 TD824-1F161F23K拖拉机

TD900.482D 48.2-车身线束安装总成 48.2-BODY HARNESS INSTALLATION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M6X12-A2L 六角头螺栓 BOLT 6 2011-11_

10 FT300.48.064 点火锁 IGNITION LOCK 1 2011-11_
11 FT800A.48L.101 过线胶圈(一) RUBBER RING (1) 1 2011-11_
12 GBT6170-M4-A2L 1型六角螺母 NUT 2 2011-11_
12 GBT6170-M4-A2L 1型六角螺母 NUT 2 2011-11_

13 GBT97.1-4-A0P 垫圈 WASHER 2 2011-11_

14 FT800.48B.068 工作灯插座 WORKING LIGHT SOCKET 1 2011-11_
15 GBT68-M4X30-A1L 开槽沉头螺钉 SCREW 2 2011-11_
16 FT800A.48L.106 过线胶圈（五） RUBBER RING (5) 1 2011-11_
17 FT800.48B.069 充电器插座 CHARGER SOCKET 1 2011-11_

18 TD800.482.3 电器盒 ELECTRIC BOX 1 2011-11_

18.1 TD800.482.3.2 闪光继电器 FLASH RELAY 1 2011-11_
18.2 TD800.482.3.3 灯光继电器 LIGHT RELAY 1 2011-11_
18.3 GE20H4.34.13-01 保险片(5A) FUSE (5A) 2 2011-11_
18.4 TD800.482.3.4 预热继电器 PREHEATING RELAY 1 2011-11_

18.5 TD800.482.3.1 主电源继电器 MAIN POWER RELAY 1 2011-11_

19 FT300.48.033 制动灯开关 BRAKE LIGHT SWITCH 2 2011-11_
2 FT300.48.055 启动继电器 STARTING RELAY 1 2011-11_
20 3724D01-201 可松式扎带 RELEASABLE TIE 6 2011-11_
3 GBT97.1-6-A0P 平垫圈 WASHER 6 2011-11_

4 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 6 2011-11_

5 GBT6170-M6-A2L 螺母 NUT 6 2011-11_
6 FT800A.48.020 车身线束总成 BODY HARNESS ASSEMBLY 1 2004-01_
6 TD900.482A.2 车身线束总成 BODY HARNESS ASSEMBLY 1 2011-05_
7 FT800A.48L.102 过线胶圈(二) RUBBER RING (2) 1 2011-11_

308
 TD824-1F161F23K拖拉机

309
 TD824-1F161F23K拖拉机

TD900.482D 48.2-车身线束安装总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

8 TD900.482A.1 左翘板开关 LEFT PADDLE SWITCH 1 2011-11_

9 FT65.48.652 四联翘板开关(二) FOUR-FUNCTION SWITCH(TWO) 1 2011-11_

310
 TD824-1F161F23K拖拉机

311
 TD824-1F161F23K拖拉机

TD800.483A 48.3-前灯线束安装总成 48.3-FRONT LAMP HARNESS INSTALLATION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 Q67405200 塑料紧箍带 PLASTIC FASTEN STRIP 1 2011-11_

10 GBT97.1-6-A0P 平垫圈 WASHER 2 2011-11_
11 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 2 2011-11_
12 GBT6170-M6-A2L 螺母 NUT 2 2011-11_
2 FT800A.48L.021 前灯线束总成 FRONT LAMP HARNESS ASSEMBLY 1

2 TD800.483A.1 前灯线束总成 FRONT LAMP HARNESS ASSEMBLY 1 2011-11_

3 FT600B.48B.031 前灯组合总成 FRONT LAMP COMBINATION ASSEMBLY 1 2011-11_
4 FT65.48.095 线束紧固夹（一） HARNESS TIGHTEN CLIP (1) 2 2011-11_
5 GBT5783-M8X16-A2L 螺栓 BOLT 3 2011-11_
6 GBT97.1-8-A0P 平垫圈 WASHER 3 2011-11_

7 GBT93-8-A0P 垫圈 WASHER 3 2011-11_

8 GBT6170-M8-A2L 螺母 NUT 1 2011-11_
9 FT65.48.340 电喇叭 ELECTRIC HORN 1 2011-11_

312
 TD824-1F161F23K拖拉机

313
 TD824-1F161F23K拖拉机

TD900.484 48.4-后灯线束安装总成 48.4-REAR LAMP HARNESS INSTALLATION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TF1004.482-01 过线胶圈 RUBBER RING 1 2011-11_

1 TF1004.482-01 过线胶圈 RUBBER RING 1 2011-11_
10 GBT97.1-12-A0P 平垫圈 WASHER 1 2011-11_
11 GBT93-12-A0P 弹簧垫圈 SPRING WASHER 1 2011-11_
12 GBT5783-M12X25-A3L 六角头螺栓 BOLT 1 2011-11_

13 FT65.48.092 穿线胶圈（3） THROUGH HARNESS WASHER 3 2 2011-11_

14 FT800A.48L.053 后照灯总成 REAR LAMP ASSEMBLY 2 2011-11_
15 FT65.48.052a 后尾灯总成 TAIL LAMP ASSEMBLY 1 2012-02_
15 FT800A.48L.052 后尾灯总成 TAIL LAMP ASSEMBLY 2 2011-11_
16 GBT6170-M5-A2L 1型六角螺母 NUT 3 2011-11_

17 GBT93-5-A0P 标准型弹簧垫圈 WASHER 3 2011-11_

18 GBT97.1-5-A0P 垫圈 WASHER 3 2011-11_
19 TD900.484.2 后挂车插座 REAR TRAILER SOCKET 1 2012-02_
19 FT65.48.080 后挂车插座 REAR TRAILER SOCKET 1 2011-11_
2 3724D01-201 可松式扎带 RELEASABLE TIE 6 2011-11_

20 GBT819.1-M5X35-A2L 十字槽沉头螺钉 CUNERSUNK FLAT HEAD SCREW WITH CROSS 3 2011-11_

3 GBT818-M4X10-A2L 十字槽盘头螺钉 RECESS 5 2011-11_
4 GBT93-4-A0P 标准型弹簧垫圈 SCREW 5 2011-11_
5 TD800.484.2 油量传感器 WASHER 1 2011-11_
6 TD900.484.1 后灯线束总成 OIL QUANTITY SENSOR 1 2011-05_
REAR LAMP HARNESS ASSEMBLY
6 TD800.484.1a 后灯线束总成 1 2004-01_
7 FT65.48.094 穿线胶圈(二) REAR LAMP HARNESS ASSEMBLY 3 2011-11_
8 FT800A.48L.088 驻车制动开关 RUBBER RING (2) 1 2011-11_
9 FT800A.48L.106 过线胶圈（五） PARKING BRAKE SWITCH 1 2011-11_
RUBBER RING (5)

314
 TD824-1F161F23K拖拉机

315
 TD824-1F161F23K拖拉机

TD800.485A 48.5-蓄电池安装总成 48.5-BATTERY INSTALLATION ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT6170-M10-A3L 螺母 NUT 2 2011-11_

10 FT65.48.112 电源线固定板 POWER WIRE FIXING PLATE 1 2011-11_
11 FT65.48.090 电源线 POWER WIRE 1
11 FT65.48.090a 蓄电池电源线 BATTERY POWER WIRE 1 2006-04_
11 FT65.48.090 电源线 POWER WIRE 1

12 FT450.48.102 蓄电池减震垫 BATTERY SHOCK ABSORPTION MAT 1 2009-11_

12 TB450.485.1 蓄电池减震垫 BATTERY SHOCK ABSORPTION MAT 1 2010-08_
12 TG1204.485-03 橡胶垫（一） RUBBER GASKET (1) 1 2011-11_
2 GBT93-10-A0P 标准型弹簧垫圈 WASHER 2 2011-11_
3 GBT97.1-10-A0P 平垫圈 WASHER 2 2011-11_

4 TG1204.485-02 电瓶压板 BATTERY PRESS PLATE 1 2011-11_

5 TG1204.485-01 电瓶U型拉杆 U-TYPE PULL ROD OF BATTERY 1 2011-11_
6 FT65.48.091 车身搭铁线 BODY GROUNDING WIRE 1 2011-11_
7 TG1204.485.1 蓄电池总成 BATTERY ASSEMBLY 1 2011-11_
8 TD800.485A-03 固定夹 LOCKING CLAMP 1 2011-11_

9 TD800.485A-04 线束紧固夹 HARNESS TIGHTEN CLIP 1 2011-11_

316
 TD824-1F161F23K拖拉机

317
 TD824-1F161F23K拖拉机

TD800.487 48.7-组合仪表总成 48.7-COMBINED INSTRUMENT ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT65.48.610c 组合仪表总成 COMBINED INSTRUMENT ASSEMBLY 1 2010-01_

1 FT700.48G.061b 组合仪表总成 COMBINED INSTRUMENT ASSEMBLY 1 2009-05_
1 FT700.48G.061a 组合仪表总成 COMBINED INSTRUMENT ASSEMBLY 1

318
 TD824-1F161F23K拖拉机

319
 TD824-1F161F23K拖拉机

FT300.49.001 49-工具箱总成 49-TOOL BOX ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M12X25-A3L 六角头螺栓 BOLT 2 2011-11_

1 FT65.49.101 提手座 HANDLE SEAT 2 2003-11_
10 FT300.49.012 工具箱焊合总成 TOOL BOX WELDMENT ASSEMBLY 1 2003-11_
2 GBT 867-4X8 半圆头铆钉 RIVET 2 2003-11_
3 FT65.49.115 提手 HANDLE 1 2003-11_

4 FT65.49.102 插销 CROSS PIN 1 2003-11_

5 GBT5783-M12X35-A3L 螺栓 BOLT 2 2003-11_
5 GBT5783-M12X35-A3L 螺栓 BOLT 2 2003-11_
6 FT65.49.103 固定支板 FIXING SUPPORT PLATE 1 2003-11_
7 GBT97.1-12-A0P 平垫圈 WASHER 2 2003-11_

8 GBT93-12-A0P 弹簧垫圈 SPRING WASHER 2 2003-11_

9 GBT6170-M12-A3L 螺母 NUT 2 2003-11_

320
 TD824-1F161F23K拖拉机

321
 TD824-1F161F23K拖拉机

TD800.501A 50.1-主油箱总成 50.1-MAIN OIL TANK ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800A.50.051 主油箱轧带总成 MAIN OIL TANK BELT ASSEMBLY 2 2011-11_

1 FT800A.50.051 主油箱轧带总成 MAIN OIL TANK BELT ASSEMBLY 2 2011-11_
10 TD800.501-05 油箱短胶垫 OIL TANK SHORT RUBBER GASKET 2 2011-11_
11 TD800.501.3 上支架焊合 UPPER BRACKET WELDMENT 1 2011-11_
12 GBT93-10-A0P 标准型弹簧垫圈 WASHER 4 2011-11_

13 GBT5783-M10X20-A3L 螺栓 BOLT 4 2011-11_

14 TD800.501.4 下支架焊合 LOWER BRACKET WELDMENT 1 2011-11_
2 GBT6170-M10-A3L 螺母 NUT 4 2011-11_
3 FT800A.50.209 主油箱轧带橡胶条 MAIN OIL TANK BELT RUBBER STRIP 2 2011-11_
4 TD800.501A.1 主油箱总成 MAIN OIL TANK ASSEMBLY 1 2011-11_

4.1 TD800.501A.1.2 主油箱焊合 MAIN OIL TANK WELDMENT 1 2011-11_

4.2 TD800.501A.1.1 油箱盖 OIL TANK COVER 1 2011-11_
4.3 FT300.50.015 滤网总成 FILTER MESH ASSEMBLY 1 2011-11_
4.4 JBT982-16 组合密封垫圈 COMBINED SEAL GASKET 1 2011-11_
4.5 FT65.50.226 放油螺塞 OIL DISCHARGING SCREW PLUG 1 2011-11_

5 GBT5783-M16X35-A3L 六角头螺栓 BOLT 2 2011-11_

6 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 2 2011-11_
7 FT800A.50.207 主油箱橡胶垫（一） MAIN OIL TANK RUBBER WASHER (1) 1 2011-11_
8 TD800.501.2 主油箱前支架焊合 MAIN OIL TANK FRONT BRACKET WELDMENT 1 2011-11_
9 TD800.502-01 油箱胶垫 OIL TANK RUBBER WASHER 2 2011-11_

322
 TD824-1F161F23K拖拉机

323
 TD824-1F161F23K拖拉机

TD800.502 50.2-副油箱总成 50.2-AUXILIARY OIL TANK ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 Q67645 卡箍 CLAMP HOOP 4 2011-11_

10 FT65.50.226 放油螺塞 OIL DISCHARGING SCREW PLUG 1 2011-11_
11 TD800.502.2 副油箱支架焊合 AUXILIARY OIL TANK BRACKET WELDMENT 2 2011-11_
11 TD800.502.2 副油箱支架焊合 AUXILIARY OIL TANK BRACKET WELDMENT 2 2011-11_
12 GBT5783-M10X20-A3L 螺栓 BOLT 4 2011-11_

13 GBT93-10-A0P 标准型弹簧垫圈 WASHER 4 2011-11_

14 TD800.502-04 排气软管 EXHAUST HOSE 1
14 TD800.505-01 呼吸软管 BREATH HOSE 1 2006-05_
15 Q673B23 钢带型弹性环箍 CLAMP 2 2011-11_
2 TD800.502-03 主副油箱连接管 MAIN/ASSISTANT OIL TANK CONNECTING PIPE 1

2 TD800.502-03a 主副油箱连接管 MAIN/ASSISTANT OIL TANK CONNECTING PIPE 1 2006-04_

3 TD800.502-05 橡胶连接管 RUBBER CONNECTING PIPE 2 2011-11_
4 TD800.502.3 副油箱扎带焊合 AUXILIARY OIL TANK FASTENING TIE 2 2011-11_
5 GBT6170-M10-A3L 螺母 WELDMENT 4 2011-11_
6 TD800.502-02 副油箱扎带橡胶条 NUT 2 2011-11_
AUXILIARY OIL TANK FASTENING TIE RUBBER
7 TD800.502.1 副油箱焊合 STRIP 1 2011-11_
8 TD800.502-01 油箱胶垫 4 2011-11_
9 JBT982-16 组合密封垫圈 AUXILIARY OIL TANK WELDMENT 1 2011-11_
OIL TANK RUBBER WASHER
COMBINED SEAL GASKET

324
 TD824-1F161F23K拖拉机

325
 TD824-1F161F23K拖拉机

TD800.503C 50.3-进出油管总成 50.3-OIL INLET/OUTLET PIPE ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 Q673B155 钢带型弹性环箍 CLAMP 2 2011-11_

10 GBT6170-M8-A0P 1型六角螺母 NUT 2
11 TD800.503A-01 安装支架 INSTALLATION BRACKET 1 2011-11_
12 FT800A.50.061a 旋装柴滤器总成 FUEL FILTER ASSEMBLY 1 2011-11_
13 TD800.503A.1 出油管总成 OIL OUTLET PIPE ASSEMBLY 1 2011-11_

2 FT800A.50P.101a 回油管 OIL RETURN PIPE 1

2 FT700.50G.121 回油管 OIL RETURN PIPE 1 2008-08_
3 FT65.50.106 空心螺栓 HOLLOW BOLT 2 2011-11_
4 JBT982-14 组合密封垫圈 COMBINED SEAL GASKET 4 2011-11_
4 JBT982-14 组合密封垫圈 COMBINED SEAL GASKET 4 2011-11_

5 FT800A.50.162 油管接头 JOINT 1 2011-11_

6 TD800.503C.1 输油管总成 OIL CONVEYING PIPE ASSEMBLY 1 2011-11_
6 TD800.503C.1 输油管总成 OIL CONVEYING PIPE ASSEMBLY 1 2011-11_
8 GBT97.1-8-A0P 平垫圈 WASHER 2 2011-11_
9 GBT93-8-A0P 垫圈 WASHER 2 2011-11_

326
 TD824-1F161F23K拖拉机

327
 TD824-1F161F23K拖拉机

TD800.55D-1 55.1-提升器装置总成-1 LIFT INSTALLATION ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0.1 TD-B02223 TD提升器维修包 RISER KIT 1 2014-01_

1 TA700.55A.7 螺塞总成 PLUG,THREADED 1 2013-05_
1 FT300.55B.029 油管塞总成 OIL PIPE PLUG ASSEMBLY 1 2011-11_
1.1 FT700.55D.029 手轮总成Ⅰ HANDLE WHEEL ASSEMBLY I 1 2011-11_
1.2 JBT982-8 组合垫圈 COMBINED GASKET 1 2011-11_

1.3 FT700.55D.129 盖板 COVER PLATE 1 2011-11_

1.4 FT300.55B.165 张紧胶套 TENSION RUBBER SLEEVE 1 2011-11_
1.5 FT300.55B.166 调节螺母 ADJUSTING NUT 1 2011-11_
1.6 GBT91-3.2X16-A0P 开口销 PIN 1 2011-11_
10 TD800.55B-02 六角头螺栓 BOLT 8 2011-11_

11 GBT93-12-A0P 弹簧垫圈 SPRING WASHER 12 2011-11_

12 FT700.55D.147 空心螺栓 HOLLOW BOLT 1 2011-11_
13 JBT982-8 组合垫圈 COMBINED GASKET 2 2011-11_
14 TD800.55B.4 呼吸连接钢管总成 BREATH CONNECT STEEL PIPE ASSEMBLY 1 2011-11_
15 FT800.55.120a 连接螺栓 CONNECTING BOLT 1 2011-11_

16 GBT5783-M12X40-A3L 螺栓 BOLT 2 2011-11_

17 FT800.55.119b 上拉杆支座 UPPER PULL ROD SUPPORT SEAT 1 2011-11_
18 GBT91-4X36-A0P 开口销 PIN 1 2011-11_
19 GBT6181-M20-A9L 螺母 NUT 1 2011-11_
19 GBT6181-M20-A9L 螺母 NUT 1 2011-11_

2 GBT5781-M8X30-A2L 六角头螺栓 BOLT 3 2011-11_

21 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 4 2011-11_
22 GBT6170-M16-A2L 螺母 NUT 4 2011-11_
23 TD800.55D.1 提升器总成 LIFTER ASSEMBLY 1 2011-11_
24 GBT899-GM16-M16X50-8.8-A3L 双头螺柱 8.8-A3L STUD 8 2011-11_

328
 TD824-1F161F23K拖拉机

329
 TD824-1F161F23K拖拉机

TD800.55D-1 55.1-提升器装置总成-1(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

25 TA700.55.4 油位标尺总成 DIPSTICK ASSEMBLY 1 2011-11_

25.1 2011.10.15 油位标尺总成 DIPSTICK ASSEMBLY 1 2011-11_
26 TD800.55B.2 加油管焊合 OIL FILLING PIPE WELDMENT 1 2011-11_
3 GBT93-8-A0P 垫圈 WASHER 4 2011-11_
4 Q67516 A型蜗杆传动式软管环箍 A-TYPE WORM TRANSMISSION HOSE CLAMP 4 2011-11_

5 TD800.55B.3-01 连接胶管 CONNECTING RUBBER PIPE 2 2011-11_

6 GBT5783-M8X16-A2L 螺栓 BOLT 1 2011-11_
7 GBT97.1-8-A0P 平垫圈 WASHER 1 2011-11_
8 TD800.55B.3 呼吸器总成 1 2011-11_
8.1 FT700.55D.136 呼吸器盖 RESPIRATOR COVER 1 2011-11_

8.1 FT700.55D.136 呼吸器盖 RESPIRATOR COVER 1 2011-11_

8.2 GBT893.1-26 孔用弹性挡圈 SNAP RING 1 2011-11_
8.3 FT650.40.167 座板 SEAT PLATE 2 2011-11_
8.4 FT700.55D.109 呼吸器滤芯 BREATH FILTER ELEMENT 1 2011-11_
8.5 TD800.55B.3.1 呼吸体焊合 BREATHER BODY WELDMENT 1 2011-11_

9 GBT3452.1-34.5X2.65G 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_

330
 TD824-1F161F23K拖拉机

331
 TD824-1F161F23K拖拉机

TD800.55D-2 55.2-提升器装置总成-2 LIFT INSTALLATION ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 TD800.55D.1 提升器总成 LIFTER ASSEMBLY 1 2011-11_

1 GBT5783-M10X20 螺栓 BOLT 4 2011-11_
10 650.55.159 轴套Ⅱ BUSH 2 2 2011-11_
11 650.55.158 隔套 SPACER BUSH 2 2011-11_
12 FT800.55.129B 内提升臂 INNER LIFTING ARM 1 2011-11_

13 FT800.55.130B 活塞顶杆 PISTON TOP ROD 1 2011-11_

14 GBT882-B6X74 销轴 PIN 1 2011-11_
15 GBT91-2X20 销 PIN 1 2009-11_
16 550.55.108 提升轴 LIFTING SHAFT 1 2011-11_
17 GBT5782-M8X100 六角头螺栓 BOLT 1 2011-11_

18 GBT93-8 垫圈8 WASHER 8 19 2011-11_

19 GBT5782-M8X80 六角头螺栓 BOLT 2 2009-11_
2 GBT93-10 垫圈10 WASHER 10 4 2011-11_
20 GBT5781-M8X16 六角头螺栓全螺纹C级 16 2009-11_
21 650.55.113-2 底盖板 COVER;UNDER 1 2011-11_

22 650.55.112-2 纸垫 GASKET 0.5 1 2011-11_

23 FT800.55.110A 提升器壳体 LIFTER HOUSING 1 2011-11_
24 650.55.143-2 销轴Ⅱ PIN 2 1 2011-11_
25 650.55.144 右举臂压板 RIGHT LIFT ARM PRESSURE PLATE 1 2011-11_
26 GBT91-2X14 销 PIN 2 2009-11_

27 GBT97.1-8 垫圈 WASHER 2 2011-11_

28 FT65.55.124 后调节杆 REAR ADJUSTING ROD 1 2011-11_
29 GBT6170-M10 螺母M10 NUT M10 1 2011-11_
3 650.55.116 左举臂压板 PRESSURE PLATE OF LEFT LIFT ARM 1 2011-11_
30 FT65.55.123 调节螺套 ADJUSTING SCREW SLEEVE 1 2011-11_

332
 TD824-1F161F23K拖拉机

333
 TD824-1F161F23K拖拉机

TD800.55D-2 55.2-提升器装置总成-2(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

31 FT65.55.126 螺栓 BOLT 1 2011-11_

32 FT65.55.125 前调节杆 FRONT ADJUSTING ROD 1 2011-11_
33 FT800.55.143-1 销轴Ⅰ PIN 1 2 2011-11_
34 650.55.142 中间臂 MIDDLE ARM 1 2011-11_
35 GBT97.1-10 垫圈10 WASHER 10 1 2011-11_

36 GBT91-2.5X16 开口销 PIN 1 2013-10_

4 FT800.55.107A 举臂 LIFTING ARM 2 2011-11_
5 FT800.55.106 力调节弹簧垫片 FORCE ADJUSTING SPRING WASHER 2 2011-11_
6 GBT3452.1-60X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 2 2011-11_
7 GBT3452.1-56X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 2 2011-11_

8 650.55.114 铜轴套 COPPER SHAFT SLEEVE 2 2011-11_

9 GBT3452.1-56x5.3 O形密封圈 O RING 2 2009-11_

334
 TD824-1F161F23K拖拉机

335
 TD824-1F161F23K拖拉机

TD800.55D-3 55.3-提升器装置总成-3 LIFT INSTALLATION ASSEMBLY-3

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 TD800.55D.1 提升器总成 LIFTER ASSEMBLY 1 2011-11_

1 650.55.132 活塞球座 PISTON BALL SEAT 1 2011-11_
10 GBT3452.1-12.5X2.65 O形密封圈 O RING 2 2011-11_
11 FT65.55.144a 油缸盖 OIL CYLINDER COVER 1 2011-11_
11 FT65.55.144a 油缸盖 OIL CYLINDER COVER 1 2011-11_

12 FT65.55.174 薄垫圈 THIN WASHER 1 2011-11_

13 650.55.139 安全阀螺塞 PLUG SAFETY VALVE 1 2011-11_
14 GBT3452.1-23.6X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_
14 GBT3452.1-23.6X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_
15 650.55.152 调整垫片 ADJUSTING WASHER 999 2011-11_

16 300.55.133 油缸安全阀弹簧 SAFTY VALVE SPRING OF OIL CYLINDER 1 2011-11_

17 300.55.134 油缸安全阀体 SAFTY VALVE BODY OF CYLINDER 1 2011-11_
18 650.55.136 安全阀座 SAFETY VALVE SEAT 1 2011-11_
19 GBT3452.1-19X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_
2 GBT1235-110X101X2 挡圈 RETAINER RING 2 2011-11_

20 GBT93-18 垫圈 WASHER 4 2011-11_

21 GBT5783-M18X1.5X60 螺栓 BOLT 4 2011-11_
22 GBT5783-M12X50 六角头螺栓全螺纹 BOLT 2 2011-11_
23 GBT93-12 垫圈 WASHER 2 2011-11_
24 65.55.103 空心螺栓 HOLLOW BOLT 1 2011-11_

25 CF250B.55.302 铝垫 ALUMINUM GASKET 2 2011-11_

26 650.55.149 隔套 SPACER BUSH 1 2011-11_
27 GBT57-M5X12 螺钉 SCREW 1 2011-11_
28 650.55.135 调节阀弹簧 ADJUSTING VALVE SPRING 1 2011-11_
29 GBT308-φ12 钢球 BALL 1 2011-11_

336
 TD824-1F161F23K拖拉机

337
 TD824-1F161F23K拖拉机

TD800.55D-3 55.3-提升器装置总成-3(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

3 GBT3452.1-100X5.3 O形密封圈 O RING 2 2011-11_

30 650.55.146 调节阀 ADJUSTING VALVE 1 2011-11_
31 GBT3452.1-15X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_
32 FT65.55.175 挡圈 RETAINER RING 1 2011-11_
33 FT65.55.141 调节杆 ADJUSTING ROD 1 2011-11_

34 E300.55.140A 速度下降阀手轮 SPEED DROP VALVE HAND WHEEL 1 2011-11_

34 E300.55.140A 速度下降阀手轮 SPEED DROP VALVE HAND WHEEL 1 2011-11_
35 300.55.138 销 PIN 1 2011-11_
36 GBT879-4X20 销 PIN 1 2011-11_
4 650.55.131 活塞 PISTON 1 2011-11_

4 650.55.131 活塞 PISTON 1 2011-11_

5 GBT3452.1-118X3.55 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_
6 FT65.55.109a 缸筒 CYLINDER TRUNK 1 2011-11_
7 FT65.55.121 矩形密封圈 RECTANGULAR SEAL RING 1 2011-11_
8 GBT3452.1-103X3.55 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_

9 GBT1235-110X104X1.5 挡圈 RETAINER RING 1 2011-11_

338
 TD824-1F161F23K拖拉机

339
 TD824-1F161F23K拖拉机

TD800.55D-4 55.4-提升器装置总成-4 LIFT INSTALLATION ASSEMBLY-4

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 TD800.55D.1 提升器总成 LIFTER ASSEMBLY 1 2011-11_

1 GBT1152-M10X1 油杯 OIL CUP 2 2011-11_
10 650.55.103 弹簧压板 SPRING PRESSURE PLATE 1 2011-11_
11 650.55.121 螺栓 BOLT 1 2011-11_
12 FT800.55.101 连接架 CONNECTING BRACKET 1 2009-11_

13 GBT6181-M20 螺母 NUT 1 2009-11_

14 GBT91-4X36 销 PIN 1 2009-11_
15 GBT93-16 垫圈 16 WASHER 5 2011-11_
16 FT800.55.145 销 PIN 1 2011-11_
17 FT800.55.140 连接杆 1 2011-11_

18 GBT97.1-8 垫圈 WASHER 1 2011-11_

19 GBT91-2X14 销 PIN 1 2009-11_
2 650.55.151 垫片 WASHER 1 2011-11_
20 650.55.102 力调节传感接头 FORCE ADJUSTING SENSOR JOINT 1 2011-11_
21 GBT6170-M16 螺母 NUT 4 2011-11_

22 GBT899-M16-M16X50 双头螺柱 8.8-A3L STUD 4 2011-11_

22 GBT899-M16-M16X50 螺柱 STUD 4 2011-11_
23 FT800.55.104 弹簧座 SPRING SEAT 1 2011-11_
3 FT800.55.150 放油接头 OIL DISCHARGING JOINT 1 2011-11_
4 25.55.117 输油管垫片 WASHER OF OIL CONVEYING PIPE 1 2011-11_

5 25.55.114 输油管螺母 OIL CONVEYING PIPE NUT 1 2011-11_

6 650.55.153 力调节弹簧调整垫片 ADJUSTING WASHER OF FORCE ADJUSTING 1 2011-11_
7 650.55.154 力调节弹簧 SPRING 1 2011-11_
8 GBT6171-M20X1.5-8 螺母 FORCE ADJUSTING SPRING 2 2011-11_
8 GBT6171-M20X1.5-8 1型六角螺母 NUT 2 2011-11_

340
 TD824-1F161F23K拖拉机

341
 TD824-1F161F23K拖拉机

TD800.55D-4 55.4-提升器装置总成-4(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

9 FT800.55.101a 连接架 CONNECTING BRACKET 1 2007-08_

9 GBT93-20 垫圈 WASHER 1 2013-10_

342
 TD824-1F161F23K拖拉机

343
 TD824-1F161F23K拖拉机

FT800.56.001a-1 56.1-悬挂机构总成-1 SUSPENSION MECHANISM ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.56.032b 上拉杆固定卡组合 UPPER PULL ROD FIXED CLIP COMBINATION 1 2011-11_

1.1 GBT91-2.5X14-A0P 开口销 PIN 2 2011-11_
1.1 GBT91-2.5X14-A0P 开口销 PIN 2 2011-11_
1.2 FT800.56.035d 连接板焊合件 CONNECTING PLATE WELDMENT 1 2011-11_
1.3 GBT97.1-8-A0P 平垫圈 WASHER 2 2011-11_

1.4 FT800.56.263a 固定卡 LOCKING CLAMP 1 2011-11_

2 FT800.56.017 上拉杆总成 UPPER PULL ROD ASSEMBLY 1 2011-11_
2.1 FT800.56.247 上拉杆前销 UPPER PULL ROD FRONT PIN 1 2004-01_
2.1 FT800.56.017.1 上拉杆前销 UPPER PULL ROD FRONT PIN 1 2009-11_
2.2 FT800.56.223 锁销环 LOCKING PIN RING 1 2011-11_

2.3 FT800.56.224 锁销 PIN 1 2011-11_

2.4 FT800.56.025 上拉杆前调节螺杆挤压总成 UPPER PULL ROD FRONT ADJUSTING SCREW 1 2011-11_
2.5 FT800.56.024 调节螺管手柄焊合总成 EXTRUSION ASSEMBL 1 2011-11_
2.6 FT800.56.029 上拉杆锁紧螺帽总成 ADJUSTING SCREW HANDLE WELDMENT 1 2011-11_
2.7 FT800.56.023 上拉杆后调节螺杆挤压总成 ASSEMBLY 1 2011-11_
UPPER PULL ROD LOCKING NUT ASSEMBLY
2.8 FT800.56.027 上拉杆销及锁销总成 UPPER PULL ROD REAR ADJUSTING SCREW 1 2011-11_
EXTRUSION ASSEMBLY

UPPER PULL ROD PIN AND LOCK PIN

ASSEMBLY

344
 TD824-1F161F23K拖拉机

345
 TD824-1F161F23K拖拉机

FT800.56.001a-2 56.2-悬挂机构总成-2 SUSPENSION MECHANISM ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.56.026 右限位杆连接叉焊合总成 RIGHT LIMITING ROD CONNECTING FORK WELD 1 2011-11_

10 GBT95-24-A0P 平垫圈 ASSEMBLY 2 2011-11_
11 FT800.56.014 左限位杆连接叉焊合总成 WASHER 1 2011-11_
12 GBT5783-M16X40-A3L 六角头螺栓 LEFT LIMITING ROD CONNECTING FORK WELD 8 2011-11_
13 GBT93-16-AOP 垫圈 ASSEMBLY 8 2011-11_
BOLT
2 FT800.56.011a 限位杆总成 WASHER 2 2011-11_
2.1 FT800.56.018 限位杆铆合总成 2 2011-11_
2.2 FT800.56.019 限位杆锁销总成 LIMIT ROD ASSEMBLY 2 2011-11_
2.3 FT800.56.036 限位杆导管焊合 LIMIT ROD RIVET ASSEMBLY 2 2011-11_
2.4 FT800.56.264 梯形螺母 LIMIT ROD LOCK PIN ASSEMBLY 2 2011-11_
LIMIT ROD GUIDE PIPE WELDMENT
2.5 FT800.56.107 调节螺杆 TRAPEZOIDAL NUT 2 2011-11_
3 FT800.56.101 销轴 2 2011-11_
4 FT800.56.207 弹簧锁销 ADJUSTING SCREW 6 2011-11_
5 FT800.56.103 销轴 PIN 2 2011-11_
6 FT800.56.104 限位杆螺栓 SPRING LOCK PIN 2 2011-11_
PIN
7 FT800.56.012a 下拉杆焊接总成 LIMIT ROD BOLT 2 2011-11_
8 GBT91-5X40-AOP 开口销 4 2011-11_
9 GBT9459-M24X2-A3L 六角开槽薄螺母 LOWER PULL ROD WELDMENT ASSEMBLY 4 2011-11_
PIN
NUT

346
 TD824-1F161F23K拖拉机

347
 TD824-1F161F23K拖拉机

FT800.56.001a-3 56.3-悬挂机构总成-3 SUSPENSION ASSEMBLY-3

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT800.56.112d 下拉杆支架 LOWER PULL ROD BRACKET 1 2011-11_

10 FT800.56A.041 提升杆后联接销焊合 LIFTING ROD REAR CONNECTING PIN 2 2011-11_
11 FT800.56A.261 挡板 WELDMENT 2 2011-11_
12 GBT899-M16X95-8.8-A2L 双头螺柱 RETAINER PLATE 6
13 FT800.56.102d 下拉杆支承杆 8.8-A3L STUD 1 2011-11_
SUPPORT ROD OF LOWER PULL ROD
2 GBT93-16-A0P 弹簧垫圈 6 2011-11_
3 GBT6170-M16-A2L 螺母 SPRING WASHER 6 2011-11_
4 GBT72-M8X16-A2L 开槽锥端定位螺钉 NUT 2 2011-11_
4 GBT72-M8X16-A2L 开槽锥端定位螺钉 A2L SCREW 2 2011-11_
5 GBT119-B20X35 圆柱销 A2L SCREW 2 2011-11_
PIN
6 FT800.56.124 销轴 2 2011-11_
7 FT800.56.015b 提升杆总成 PIN 2 2011-11_
7.1 FT800.56.020a 上螺杆铆合总成 LIFTING ROD ASSEMBLY 2 2011-11_
7.2 FT800.56.265 梯形螺母 UPPER SCREW ROD RIVET ASSEMBLY 2 2011-11_
7.3 FT800.56.031a 提升杆导管焊合 TRAPEZOIDAL NUT 2 2011-11_
LIFTING ROD GUIDE PIPE WELDMENT
7.4 FT800.56A.259 螺杆 2 2011-11_
7.5 FT800.56.258b 提升杆叉 2 2011-11_
7.5 FT800.56.258b 提升杆叉 LIFTING ROD FORK 2 2011-11_
7.6 FT800.56A.264 左旋梯形螺母 LIFTING ROD FORK 2 2011-11_
7.7 JBT7940.1-M10X1 直通式压注油杯 LEFT TRAPEZOIDAL NUT 2 2011-11_
STRAIGHT PRESSURE FILLING OIL CUP
8 FT800.56.262 垫圈 2 2011-11_
9 FT800.56.115 弹簧锁销Ⅱ WASHER 2 2011-11_
SPRING LOCKING PIN II

348
 TD824-1F161F23K拖拉机

349
 TD824-1F161F23K拖拉机

TD800.57C-1 57.1-分配器装配总成-1 DISTRIBUTOR INSTALLATION ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TD800.57C.1 分配器操纵机构总成 DISTRIBUTOR CONTROL MECHANISM ASSEMBLY 1 2011-11_

1.1 GBT894.1-18 挡圈 RETAINER RING 2 2013-10_
1.1 GBT894.1-20 挡圈20 BLCOKING RING 2 2011-11_
1.1 TF1004.583A.9-03 垫圈 WASHER 1 2013-10_
1.1 GBT6170-M8-A2L 螺母 NUT 3 2011-11_

1.11 FT800A.57.107 夹头 CLIP HEAD 2 2011-11_

1.12 FT800A.57.108 球面联接盖 SPHERICAL SURFACE CONNECTING COVER 1 2011-11_
1.13 FT800A.57.109a 操纵拉杆 CONTROL PULL ROD 1 2011-11_
1.14 GBT6170-M8-LH-8-A2L 1型六角螺母 NUT 1 2011-11_
1.15 FT700.58E.103 左旋球面联接盖 LEFT BALL SURFACE CONNECTING COVER 1 2011-11_

1.15 FT700.58E.103 左旋球面联接盖 LEFT BALL SURFACE CONNECTING COVER 1 2011-11_

1.2 FT800A.57.103a 限位套1 LIMITING SLEEVE I 1 2013-10_
1.3 FT800A.57.011 操纵臂焊合总成 OPERATING ARM WELDED ASSEMBLY 1 2011-11_
1.3 GBT5783-M8X30-8.8-A2L 六角头螺栓 BOLT 2 2013-10_
1.4 GBT93-8-A0P 垫圈 WASHER 2 2013-10_

1.4 TB504.552-04 手柄头总成 HANDLE HEAD ASSEMBLY 1 2010-10_

1.5 GBT6170-M8-8-A2L Ⅰ型六角螺母 I-TYPE HEXAGON NUT 3 2013-10_
1.5 GBT68-M4X10-A2L 开槽双头螺钉 1 2011-11_
1.6 FT800A.57.102a 固定轴 FIXING SHAFT 1 2013-10_
1.6 FT800A.57.103 限位套1 LIMITING SLEEVE I 2 2011-11_

1.7 FT800A.57.102 固定轴 FIXING SHAFT 1 2011-11_

1.7 TD800.57C.1.1 操纵臂压合总成1 CONTROL ARM ASSEMBLY 1 2013-10_
1.8 GBT5783-M8X30-A2L 螺栓 BOLT 2 2011-11_
1.8 TD800.57C.1.2 操纵臂压合总成1 CONTROL ARM ASSEMBLY 1 2013-10_
1.9 TD800.57C.1.3 操纵臂压合总成2 CONTROL ARM ASSEMBLY 1 2013-10_

350
 TD824-1F161F23K拖拉机

351
 TD824-1F161F23K拖拉机

TD800.57C-1 57.1-分配器装配总成-1(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1.9 GBT93-8 垫圈8 WASHER 8 2 2011-11_

2 FT800A.57.020 分配器总成 DISTRIBUTER ASSEMBLY 1 2011-11_
3 FT65.57.014 调节手柄头总成 ADJUSTING HANDLE HEAD ASSEMBLY 2 2011-11_
3 GBT68-M4X10-4.8-A2L 开槽沉头螺钉 SCREW 1 2013-10_
4 FT800A.57.124 定位弯板 LOCATING BENDING PLATE 2 2011-11_

5 FT65.57.104 定位螺母 LOCATING NUT 2 2011-11_

352
 TD824-1F161F23K拖拉机

353
 TD824-1F161F23K拖拉机

TD800.57C-2 57.2-分配器装配总成-2 DISTRIBUTOR INSTALLATION ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

.5 FT800A.57.020 分配器总成 DISTRIBUTER ASSEMBLY 1 2011-11_

1 GBT5783-M6X75 螺栓 BOLT 4 2011-11_
10 T30.57.102-1 回油阀堵塞 OIL RETURN VALVE PLUG 1 2011-11_
11 T30.57.122A 主控制阀 MAIN CONTROL VALVE 1 2011-11_
12 T30.57.112 主阀弹簧 MAIN VALVE SPRING 1 2011-11_

13 GBT3452.1-19X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 3 2011-11_

14 T30.57.113 主阀前盖 MAIN VALVE FRONT COVER 1 2011-11_
15 GBT70-M6X16 内六角圆柱头螺钉 SCREW 3 2011-11_
16 T30.57.127 安全阀座 SAFETY VALVE SEAT 1 2011-11_
17 T30.57.128 安全阀堵头 SAFETY VALVE PLUG 1 2011-11_

18 T30.57.107 安全阀体 SAFETY VALVE BODY 1 2011-11_

18 T30.57.107 安全阀体 SAFETY VALVE BODY 1 2011-11_
19 T30.57.106 安全阀弹簧 SAFETY VALVE SPRING 1 2011-11_
2 GBT93-6 垫圈 WASHER 7 2011-11_
20 FT65.57.133 调整垫片 ADJUSTING WASHER 1 2010-01_

20 T30.57.156~158 调整垫片 ADJUSTING WASHER 1 2013-10_

21 T30.57.105 安全阀弹簧座 SPRING SEAT OF SAFETY VALVE 1 2011-11_
3 FT800A.57.122 侧盖 SIDE COVER 1 2011-11_
4 T30.57.118 纸垫 GASKET 0.5 1 2011-11_
5 T30.57.115-2A 分配器壳体 DISTRIBUTOR HOUSING 1 2011-11_

6 GBT3452.1-11.8X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 2 2011-11_

6 GBT3452.1-11.8X2.65 O形密封圈 O RING 2 2011-11_
7 T30.57.104-2 回油阀体 OIL RETURN VALVE BODY 1 2011-11_
8 T30.57.103-1 回油阀弹簧 SPRING 1 2011-11_
9 GBT3452.1-21.2X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_

354
 TD824-1F161F23K拖拉机

355
 TD824-1F161F23K拖拉机

TD800.57C-3 57.3-分配器装配总成-3 DISTRIBUTOR INSTALLATION ASSEMBLY-3

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 FT800A.57.020 分配器总成 DISTRIBUTER ASSEMBLY 1 2011-11_

1 T30.57.145B 单向阀堵塞 ONE-WAY VALVE PLUG 1 2011-11_
10 T30.57.140-1 下降阀弹簧 DOWNWARD VALVE SPRING 1 2011-11_
11 GBT308-φ5.0000G40b 钢球 BALL 1 2013-10_
11 GBT308-5-G100-b 钢球 BALL 1 2010-01_

12 T30.57.139 下降阀体 DOWNWARD VALVE BODY 1 2011-11_

13 T30.57.114 推销 PUSH PIN 1 2011-11_
14 T30.57.138 下降阀套 DOWNWARD VALVE SLEEVE 1 2011-11_
15 T30.57.159~161 调整垫片 ADJUSTING WASHER 999 2013-10_
2 GBT3452.1-22.4X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 1 2013-10_

2 FT800A.57.013 单面摩擦盘总成 SINGLE FRICTION DISC ASSEMBLY 1 2013-07_

3 T30.57.144B 单向阀弹簧 ONE-WAY VALVE SPRING 1 2011-11_
4 T30.57.164 单向阀体垫 ONE-WAY VALVE BODY GASKET 1 2011-11_
5 T30.57.142B 单向阀体 ONE-WAY VALVE BODY 1 2011-11_
6 T30.57.143B 单向阀座 ONE-WAY VALVE SEAT 1 2011-11_

7 GBT3452.1-19X2.65 液压气动用O形橡胶密封圈 O-SEAL RING 3 2011-11_

8 T30.57.137 下降阀堵塞 DOWNWARD VALVE PLUG 1 2011-11_
9 GBT3452.1-16X1.8 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_

356
 TD824-1F161F23K拖拉机

357
 TD824-1F161F23K拖拉机

TD800.57C-4 57.4-分配器装配总成-4 DISTRIBUTOR INSTALLATION ASSEMBLY-4

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

0 FT800A.57.020 分配器总成 DISTRIBUTER ASSEMBLY 1 2011-11_

1 GBT879-5X24 销 PIN 3 2011-11_
10 GBT97.1-8 垫圈 WASHER 1 2011-11_
11 FT800A.57.120 手柄轴 HANDLE SHAFT 1 2011-11_
12 FT800A.57.119 限位套4 LIMITING SLEEVE 4 3 2011-11_

13 FT800A.57.114 固定板 FIXED PLATE 1 2011-11_

14 FT800A.57.112 弹簧 SPRING 1 2011-11_
15 FT800A.57.013 单面摩擦盘总成 SINGLE FRICTION DISC ASSEMBLY 2 2011-11_
16 FT800A.57.118 操纵曲柄 CONTROL CRANK 1 2011-11_
17 GBT879-5X35 销 PIN 1 2011-11_

18 FT800A.57.110 挡板 RETAINER PLATE 1 2011-11_

19 GBT899-GM10-M10X60-8.8 螺栓 BOLT 3 2011-11_
2 E300.57.135 销轴 PIN 1 2011-11_
20 GBT93-10 垫圈10 WASHER 10 3 2011-11_
21 GBT6170-M10 螺母M10 NUT M10 3 2011-11_

22 FT800A.57.113 球头 BALL JOINT 1 2013-10_

3 T30.57.133-2 反馈臂 FEEDBACK ARM 1 2011-11_
4 T30.57.109 反馈轴 FEEDBACK SHAFT 1 2011-11_
5 GBT3452.1-9.5X2.65 O形密封圈 O RING 2 2011-11_
6 T30.57.120 反馈小臂 FEEDBACK ARM 1 2011-11_

7 T30.57.125 销轴 PIN 1 2011-11_

8 GBT91-2X12 开口销 PIN 1 2011-11_
9 T30.57.119 摆杆 UPPER PART U-HOOK 1 2011-11_

358
 TD824-1F161F23K拖拉机

359
 TD824-1F161F23K拖拉机

FT804A.58H.001 58-油泵油管滤油器总成 58-OIL PUMP/PIPE/FILTER ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT700.58G.103 空心螺栓-2 HOLLOW BOLT -2 1 2004-01_

10 FT700.58G.010 齿轮泵 GEAR PUMP 1 2004-01_
10 FT700.58B.020 齿轮泵 GEAR PUMP 1 2009-01_
11 GBT93-10-A0P 标准型弹簧垫圈 WASHER 2 2011-11_
12 GBT5783-M10X30-A3L 螺栓 BOLT 2 2011-11_

13 JBT982-27 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_

13 JBT982-27 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_
14 FT750.58.050 吸油短管焊合-2 OIL SUCTION SHORT PIPE WELDMENT-2 1 2011-11_
14 FT750.58.050 吸油短管焊合-2 OIL SUCTION SHORT PIPE WELDMENT-2 1 2011-11_
15 FT700.58G.101 空心螺栓-1 HOLLOW BOLT -1 1 2011-11_

16 JBT8870-d40 喉箍 HOOP 4 2011-11_

17 FT650.58.105 胶管 RUBBER HOSE 2 2011-11_
18 GBT5783-M8X20-A2L 螺栓 BOLT 4 2011-11_
19 GBT93-8-A0P 垫圈 WASHER 6 2011-11_
2 JBT982-22 组合密封垫圈 COMBINED SEAL GASKET 2 2009-01_

2 JBT982-18 组合密封垫圈 COMBINED SEAL GASKET 2 2004-01_

2 JBT982-18 组合密封垫圈 COMBINED SEAL GASKET 2 2004-01_
20 FT750.58.040 吸油短管焊合-1 OIL SUCTION SHORT PIPE WELDMENT-1 1 2011-11_
21 GBT3452.1-32.5X2.65G 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_
22 FT804A.58.080 滤油器总成 OIL FILTER ASSEMBLY 1 2011-11_

22.1 FT804A.58.080-01 滤芯 FILTER 1 2011-11_

23 GBT97.1-8-A0P 平垫圈 WASHER 2 2011-11_
24 FT750.58.030 吸油长管焊合 OIL SUCTION LONG PIPE WELDMENT 1 2011-11_
25 GBT5783-M8X50-A2L 六角头螺栓 BOLT 2
26 GBT3452.1-26.5X2.65G 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_

360
 TD824-1F161F23K拖拉机

361
 TD824-1F161F23K拖拉机

FT804A.58H.001 58-油泵油管滤油器总成(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

3 FT700.58G.021 压力油管焊合-1 PRESSURE OIL PIPE WELDMENT-1 1 2004-01_

3 TD800.581.2 油泵出油管焊合 OIL PUMP OUTPUT PIPE WELDMENT 1 2011-09_
3 FT700.58G.021a 压力油管焊合-1 PRESSURE OIL PIPE WELDMENT-1 1 2009-01_
4 FT700.58A.101 卡套式直通接头体 JOINT 2 2011-11_
5 GBT5783-M6X30-A2L 螺栓 BOLT 3 2011-11_

6 GBT93-6-A0P 弹簧垫圈 SPRING WASHER 3 2011-11_

7 FT650.58.060 油管夹与胶垫胶合 OIL PIPE CLAMP AND RUBBER WASHER 6 2011-11_
8 GBT6170-M6-A2L 螺母 NUT 3 2011-11_
9 FT804A.58.020 压力油管总成-2 PRESSURE OIL PIPE ASSEMBLY-2 1 2011-11_
9 FT804A.58.020a 高压油管总成 HIGH PRESSURE OIL PIPE ASSEMBLY 1 2011-09_

362
 TD824-1F161F23K拖拉机

363
 TD824-1F161F23K拖拉机

TD904.582A-1 58.2.1-多路阀油管总成-1 MULTI-WAY VALVE OIL PIPE ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT654.58.020 多路阀总成 MULTI-WAY VALVE ASSEMBLY 1 2011-11_

10 FT804A.58L.021 操纵杆焊合-1 CONTROL ROD WELDMENT-1 1 2011-11_
11 FT804A.58L.133 右旋拉杆叉 RIGHT REVOLVING PULL ROD FORK 2 2011-11_
12 FT804A.58L.134 拉杆 PULL ROD 2 2011-11_
13 FT804A.58L.136 左旋拉杆叉 LEFT REVOLVING PULL ROD FORK 2 2011-11_

2 GBT91-2X12-A0P 开口销 PIN 10 2011-11_

3 GBT97.1-6-A0P 平垫圈 WASHER 8 2011-11_
4 GBT882-B6X24-A0P 销轴 PIN 2 2011-11_
5 FT654.58.103 联接板 CONNECTING PLATE 4 2011-11_
6 FT804A.58L.132 摇臂 ROCKER 2 2011-11_

7 GBT882-B6X28-A0P 销轴 PIN 6 2011-11_

8 FT65.57.013 手柄头总成 HANDLE HEAD ASSEMBLY 2 2004-01_
8 FT65.57.013 手柄头总成 HANDLE HEAD ASSEMBLY 2 2004-01_
8 TB504.552-04 手柄头总成 HANDLE HEAD ASSEMBLY 2 2010-10_
9 FT804A.58L.022 操纵杆焊合-2 CONTROL ROD WELDMENT-2 1 2011-11_

364
 TD824-1F161F23K拖拉机

365
 TD824-1F161F23K拖拉机

TD904.582A-2 58.2.2-多路阀油管总成-2 MULTI-WAY VALVE OIL PIPE ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT354.58A.103 防尘盖 DUSTPROOF COVER 4 2011-11_

10 JBT982-18 组合密封垫圈 COMBINED SEAL GASKET 4 2011-11_
10 JBT982-18 组合密封垫圈 COMBINED SEAL GASKET 4 2011-11_
11 GBT6170-M10-A3L 螺母 NUT 3 2013-07_
12 GBT93-10-A0P 标准型弹簧垫圈 WASHER 4 2011-11_

13 GBT3452.1-12.5X2.65G 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_

14 GBT93-8-A0P 垫圈 WASHER 2 2011-11_
15 GBT5783-M8X35-A2L 六角头螺栓 BOLT 2 2013-07_
16 FT904.58A.020 分配器进油管焊合 DISTRIBUTOR OIL INLET PIPE WELDMENT 1 2011-11_
17 FT654.58.020 多路阀总成 MULTI-WAY VALVE ASSEMBLY 1 2011-11_

18 GBT95-10-A0P 垫圈 WASHER 4 2011-11_

19 GBT5782-M10X70-A2L 六角头螺栓 BOLT 3 2011-11_
2 FT654.58.010a 快换接头 QUICK CHANGING JOINT 4 2011-11_
20 FT804.58L.012 多路阀安装支架焊合 MULTI-WAY VALVE INSTALLATION BRACKET 1 2011-11_
21 GBT5783-M10X20-A3L 螺栓 WELDMENT 1 2011-11_
BOLT
22 FT800.55.151 放油螺母 1 2011-11_
23 JBT982-20 组合密封垫圈 OIL DISCHARGING NUT 2 2011-11_
24 JBT982-22 组合密封垫圈 COMBINED SEAL GASKET 3 2011-11_
25 TD904.582-01 放油空心螺栓 COMBINED SEAL GASKET 1 2007-10_
25 FT804.58.101 空心螺栓 OIL DISCHARGING HOLLOW BOLT 1 2004-01_
HOLLOW BOLT
26 FT804.58L.013 回油管焊合-1 1 2011-11_
27 FT654.58B.102 卡套式端直通接头体1 OIL RETURN PIPE WELDMENT-1 2 2011-11_
28 FT904.58A.010 多路阀进油管总成 STRAIGHT THREAD JOINT BODY 1 1 2011-11_
3 FT654.58B.101b 油管接头 MULTI-WAY VALVE OIL INLET PIPE ASSEMBLY 4 2011-11_
4 GBT6173-M27X2-A0P 六角薄螺母 JOINT 4 2011-11_

366
 TD824-1F161F23K拖拉机

367
 TD824-1F161F23K拖拉机

TD904.582A-2 58.2.2-多路阀油管总成-2(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

5 FT804.58.040 输出油管焊合-1-2 OIL OUTLET PIPE WELDMENT-1-2 1 2011-11_

6 FT804.58.060 输出油管焊合-2-1 OIL OUTLET PIPE WELDMENT-2-1 1 2011-11_
7 FT804.58.030 输出油管焊合-1-1 OIL OUTLET PIPE WELDMENT-1-1 1 2011-11_
8 FT804.58.050 输出油管焊合-2-2 OIL OUTLET PIPE WELDMENT-2-2 1 2011-11_
9 FT804.58.112 卡套式端直通接头体 STRAIGHT PIPE JOINT BODY 4 2011-11_

368
 TD824-1F161F23K拖拉机

369
 TD824-1F161F23K拖拉机

TD800.583A 58.3-单路液压输出总成 58.3-SINGLE-WAY HYDRAULIC OUTPUT ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 FT354.58A.103 防尘盖 DUSTPROOF COVER 1 2011-11_

2 FT354.58A.030 快换接头 QUICK CHANGING JOINT 1 2011-11_
3 FT754.58.102 油管接头 JOINT 1 2011-11_
4 GBT6173-M27X2-A3L 六角薄螺母 NUT 1 2011-11_
5 FT800.55.021 液压输出管焊合 HYDRAULIC OUTPUT PIPE WELDMENT 1 2011-11_

370
 TD824-1F161F23K拖拉机

371
 TD824-1F161F23K拖拉机

TA600.62ZC 62-安全带 62-SAFETY BELT

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TA600.62 安全带安装总成 SAFETY BELT INSTALLATION ASSEMBLY 1 2012-01_

372
 TD824-1F161F23K拖拉机

373
 TD824-1F161F23K拖拉机

FT800.74B.001 74-前配重总成 74-FRONT BALLAST ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT6170-M16-8-A3L 1型六角螺母 NUT 2 2011-11_

10 FT650.74.107 牵引耳 TOWING LUG 1 2011-11_
11 GBT97.1-20-A0P 垫圈 WASHER 2 2011-11_
11 GBT97.1-20-A0P 垫圈 WASHER 2 2011-11_
12 GBT5785-M20X1.5X80-A3L 螺栓 BOLT 2 2011-11_

2 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 10 2011-11_

3 GBT97.1-16-A0P 垫圈 WASHER 10 2011-11_
4 FT700.74B.010 右固定块焊接总成 RIGHT FIXING BLOCK WELDMENT ASSEMBLY 1 2011-11_
5 GBT5783-M16X35-A3L 六角头螺栓 BOLT 8 2011-11_
6 FT700.74B.011 左固定块焊接总成 LEFT FIXING BLOCK WELDMENT ASSEMBLY 1 2011-11_

7 FT800.74B.106a 配重块 BALLAST 11 2011-11_

8 F700.74B.107 联接螺栓 CONNECTING BOLT 1 2011-11_
9 FT650.74.108 牵引螺母 TOWING NUT 2 2004-01_
9 TA700.741-02 牵引板 TOWING PLATE 2 2009-12_

374
 TD824-1F161F23K拖拉机

375
 TD824-1F161F23K拖拉机

FT800.74B.002 74-前配重架总成 74-FRONT BALLAST BRACKET ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5785-M18X1.5X70-10.9-A3L 六角头螺栓 BOLT 6 2004-01_

2 GBT93-18-AOP 弹簧垫圈 SPRING WASHER 6 2004-01_
3 GBT97.1-18-A0P 平垫圈 WASHER 6 2004-01_
4 FT800.74B.105a 配重架 BALLAST BRACKET 1 2009-08_
4 FT800.74B.105 配重架 BALLAST BRACKET 1 2008-03_

376
 TD824-1F161F23K拖拉机

377
 TD824-1F161F23K拖拉机

FT800.91B.001 91-后配重总成 91-REAR BALLAST ASSEMBLY

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT5783-M16X40-A3L 六角头螺栓 BOLT 6 2011-11_

2 GBT93-16-AOP 垫圈 WASHER 12 2004-01_
2 GBT93-16-A0P 弹簧垫圈 SPRING WASHER 12 2012-09_
3 FT800.34.108 平垫圈 WASHER 12 2011-11_
4 FT804.91.105 后配重 REAR BALLAST 2 2011-11_

5 FT804.91.102 配重螺钉Ⅱ BALLAST SCREW II 6 2011-11_

6 FT800.91B.103 后配重Ⅱ REAR BALLAST II 2 2011-11_
7 FT804.91.101 配重螺钉Ⅰ BALLAST SCREW I 6 2011-11_
8 GBT97.1-16-AOP 垫圈 WASHER 6 2004-01_
9 GBT6170-M16-A3L 螺母 M16-A3L NUT 6 2011-11_

378
 TD824-1F161F23K拖拉机

379
 TD824-1F161F23K拖拉机

TD804.311-1 前桥总成-1 31FRONT AXLE ASSEMBLY-1

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 TD804.311.2 前驱动桥前支座总成 FRONT DRIVING AXLE FRONT SEAT ASSEMBLY 1 2011-11_

1.1 FT804.31.108 前驱动桥前支座 FRONT DRIVING AXLE FRONT SEAT 1 2011-11_
1.2 FT804.31.109 前驱动桥前座衬套 FRONT DRIVING AXLE FRONT SEAT BUSH 1 2011-11_
10 TD804.311-02-99.6X5.3G O形圈 O-RING 2 2011-11_
11 TD804.311.1 前驱动桥后支座总成 FRONT DRIVING AXLE REAR SEAT ASSEMBLY 1 2011-11_

11.1 FT804.31.103 前驱动桥后座衬套 FRONT DRIVING AXLE REAR SEAT BUSH 1 2011-11_
11.2 FT804.31.104 前驱动桥后安装座 FRONT DRIVING AXLE REAR INSTALLATION 1 2011-11_
12 FT654.32.104 垫圈 SEAT 16 2011-11_
12 FT654.32.104 垫圈 WASHER 16 2011-11_
13 GBT5786-M16X1.5X40-10.9-A3L 六角头螺栓 WASHER 16 2011-11_
BOLT
2 GBT119.1-12h8X24-A0P 圆柱销 4
2 GBT119.1-12h8X24-A0P 圆柱销 PIN 4
3 JBT7940.1-M10X1 直通式压注油杯 PIN 3 2011-11_
4 GBT93-18-AOP 弹簧垫圈 STRAIGHT PRESSURE FILLING OIL CUP 4 2011-11_
5 GBT5786-M18X1.5X60-A3L 六角头螺栓 SPRING WASHER 4 2011-11_
BOLT
6 TD804.311-01-52.6X3.55G O形圈 1 2011-11_
7 FT804.31.110 垫环 O-RING 1 2011-11_
7 FT804.31.110 垫环 PAD RING 1 2011-11_
8 GBT119.1-5h8X12-AOP 销 PAD RING 1 2011-11_
9 FT804.31.012 31-前驱动桥总成 PIN 1 2011-11_
31-FRONT DRIVING AXLE ASSEMBLY

380
 TD824-1F161F23K拖拉机

381
 TD824-1F161F23K拖拉机

TD804.311-2 前桥总成-2 31FRONT AXLE ASSEMBLY-2

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 5144521/11 前桥壳体 FRONT AXLE HOUSING 1 2011-11_

10 5126628-FT/1.40.211 限位螺栓M12X1.25X42 2 2011-11_
11 5126628-FT/12 隔套 SPACER BUSH 999 2011-11_
12 5119699/1.40.240 主销球铰副 MAIN PIN SPHERICAL HINGE SET 4 2011-11_
13 5121471/1.40.232 密封圈 SEAL RING 4 2011-11_

14 GBT5786-M10X1.25X20 六角头螺栓 BOLT 2 2011-11_

15 562659/1.41.032 调整螺母锁片 ADJUSTING NUT LOCK 2 2011-11_
16 4996751/1.41.015 调整螺母止动片 ADJUSTING NUT THRUST PIECE 2 2011-11_
17 4996748/1.41.005 锥传动支座瓦盖 TAPER TRANSSMISSION SEAT COVER 2 2011-11_
18 14275334/10357/04 锁紧螺栓 LOCK BOLT 4 2011-11_

19 4996750/1.41.008 调整螺母 ADJUSTING NUT 2 2011-11_

2 10305114/14530 螺塞 SCREW PLUG 2 2011-11_
20 5144525/15 锥传动支座 TAPER TRANSMISSION SEAT 1 2011-11_
21 14274634/10357/04 锁紧螺栓M12X1.25X35 10 2011-11_
22 5136119/15 后减摩环 REAR WEARING WASHER 1 2011-11_

23 5136120/15 锥传动支座轴套 TAPER TRANSMISSION SEAT SHAFT SLEEVE 1 2011-11_

24 11068376/12245 挡圈35 RETAINER RING 2 2011-11_
25 4996755/1.40.038 半轴轴承座 HALF SHAFT BEARING SEAT 2 2011-11_
26 11061076/12246 挡圈 RETAINER RING 4 2011-11_
27 GBT307-6007 轴承 BEARING 2 2011-11_

28 5136002/1.41.538 油封 OIL SEAL 2 2011-11_

29 4996762/1.41.537 半轴油封挡圈 HALF SHAFT OIL SEAL RETAINER RING 2 2011-11_
3 JBT982-22 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_
30 4966231/1.40.023 O形密封圈 O RING 2 2011-11_
31 5142040/20 右万向传动轴 RIGHT UNIVERSAL TRANSMISSION SHAFT 1 2011-11_

382
 TD824-1F161F23K拖拉机

383
 TD824-1F161F23K拖拉机

TD804.311-2 前桥总成-2(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

4 4966244/1.41.016 定位销 THIMBLE 6 2011-11_

5 5140017/11 前桥摆销 FRONT AXLE SWING PIN 1 2011-11_
6 5100194/1.40.045 限位螺钉 LIMIT SCREW 2 2011-11_
7 14048814/10128 螺母 NUT 2 2011-11_
8 13413290/24628 通气塞总成 VENT PLUG ASSEMBLY 1 2011-11_

9 4988170/1.40.021 定位销 THIMBLE 2 2011-11_

384
 TD824-1F161F23K拖拉机

385
 TD824-1F161F23K拖拉机

TD804.311-3 前桥总成-3 31FRONT AXLE ASSEMBLY-3

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 5133799/1.41.539 驱动叉轴油封 DRIVING FORK SHAFT OIL SEAL 2 2011-11_

10 14274534/10352/04 螺栓M12X1.25X30 12 2011-11_
11 GBT1152-M10X1 油杯 OIL CUP 4 2011-11_
12 5140018/20 轴用挡圈 RETAINER RING FOR SHAFT 4 2011-11_
13 5137107/20 太阳轮 SUN GEAR 4 2011-11_

14 4997571/1.41.549 齿圈挡环 GEAR RETAINER RING 2 2011-11_

15 5142047/20 齿圈支座 GEAR RING SUPPORT SEAT 2 2011-11_
16 5108749/1.41.543 齿圈 GEAR RING 2 2011-11_
17 5142020/12 锁紧螺母 LOCKING NUT 2 2011-11_
18 5137689/20 行星架 PLANET CARRIER 2 2011-11_

19 JBT982-22 组合密封垫圈 COMBINED SEAL GASKET 2 2011-11_

2 5104199/1.40.228 转向节衬套 STEERING BURL BUSH 2 2011-11_
20 10305114/14530 螺塞 SCREW PLUG 2 2011-11_
21 14233634/10357/04 螺栓 BOLT 24 2011-11_
22 4997509/1.41.547 行星齿轮轴 PLANET GEAR SHAFT 6 2011-11_

22 4997509/1.41.547 行星齿轮轴 PLANET GEAR SHAFT 6 2011-11_

23 4997510/1.41.552 行星齿轮轴承挡圈 PLANET GEAR BEARING RETAINER RING 12 2011-11_
24 5101693/1.41.546 滚针 NEEDLE 19 2011-11_
25 5108747/1.41.545 行星齿轮 PLANETARY GEAR 6 2011-11_
3 5142230-FT/12 左转向节 LEFT STEERING BURL 1 2011-11_

3.1 5142232-FT/12 右转向节 RIGHT STEERING BURL 1 2011-11_

4 8A5137109/12 轮毂油封 HUB OIL SEAL 2 2011-11_
5 5136951/12 前轮毂轴承 FRONT HUB BEARING 4 2011-11_
6 8A5142013/13 前驱动轮毂 FRONT DRIVING HUB 2 2011-11_
7 4985063/1.21.067 定位销 THIMBLE 4 2011-11_

386
 TD824-1F161F23K拖拉机

387
 TD824-1F161F23K拖拉机

TD804.311-3 前桥总成-3(续)
标号 代号 名称 数量 备注
No. Code Description Quantity Remark

8 5137457/12 调整垫片 ADJUSTING WASHER 999 2011-11_

9 5137239/12 转向节主销 PIN 4 2011-11_

388
 TD824-1F161F23K拖拉机

389
 TD824-1F161F23K拖拉机

TD804.311-4 前桥总成-4 31FRONT AXLE ASSEMBLY-4

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 5143242/16 锁紧螺母 LOCKING NUT 1 2011-11_

10 5142024/16 小锥齿轮轴 SMALL TAPER GEAR SHAFT 1 2011-11_
11 5111094/16 大锥齿轮 BIG TAPER GEAR 1 2011-11_
12 GBT307-32012 轴承 BEARING 2 2011-11_
13 4996747/1.41.402 差速器壳体 DIFFERENTIAL HOUSING 1 2011-11_

14 14274434/10357/04 螺栓 BOLT 8 2011-11_

15 4987976/1.32.428 销钉 PIN 1 2011-11_
16 4987975/1.32.425 行星齿轮止推垫圈 PLANET GEAR THRUST WASHER 2 2011-11_
17 885103870/1.32.415B 行星齿轮 PLANETARY GEAR 2 2011-11_
18 5148935/1.32.416 差速器行星齿轮轴 DIFFERENTIAL PLANETARY GEAR SHAFT 1 2011-11_

19 5148936/1.32.424 半轴齿轮止推垫圈 HALF SHAFT GEAR THRUST WASHER 999 2011-11_

2 4997451/1.41.143 油封挡圈 OIL SEAL RETAINER RING 1 2011-11_
20 5103868/1.32.413 左半轴齿轮 LEFT HALF SHAFT GEAR 1 2011-11_
21 5110716/1.41.502 右半轴齿轮 RIGHT HALF SHAFT GEAR 1 2011-11_
3 5135294/16-45X75X12 油封 OIL SEAL 1

4 GBT3452.1-31.5X1.8 液压气动用O形橡胶密封圈 O-SEAL RING 1 2011-11_

6 5142026/16 小锥齿轮轴油封环 OIL SEAL RING OF SMALL TAPER PINION 1 2011-11_
7 5133776/16 后轴承 SHAFT 1 2011-11_
8 5143109/16 前轴承 REAR BEARING 1 2011-11_
9 5142032/16 调整垫圈 FRONT BEARING 1 2011-11_
ADJUSTING WASHER

390
 TD824-1F161F23K拖拉机

391
 TD824-1F161F23K拖拉机

TD804.311-5 前桥总成-5 31FRONT AXLE ASSEMBLY-5

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 GBT894.1-25 挡圈 RETAINER RING 1 2011-11_

10 10184314/14256 空心螺栓 HOLLOW BOLT 2 2011-11_
11 5142236/22 油缸销总成 OIL CYLINDER PIN ASSEMBLY 1 2011-11_
12 GBT7244-8 垫圈 WASHER 1 2011-11_
13 GBT5783-M8X16 螺栓 BOLT 1 2011-11_

14 5111576/1.63.591 油缸销垫圈 CYLINDER PIN WASHER 1 2011-11_

15 GBT5783-M6X16 螺栓 BOLT 1 2011-11_
16 GBT7244-6 重型弹簧垫圈 1 2011-11_
17 4999554/1.63.583 油管夹子 OIL PIPE CLIP 1 2011-11_
18 5138294/1.63.22 支板 BRANCH PLATE 1 2011-11_

19 5145031/22 左转向输油管总成 LEFT STEERING OIL PIPE ASSEMBLY 1 2011-11_

2 5111573/1.63.589 油缸销垫圈 CYLINDER PIN WASHER 2 2011-11_
20 5142238/22 右转向输油管总成 RIGHT STEERING OIL PIPE ASSEMBLY 1 2011-11_
21 12576014/10125 锁紧螺母 LOCKING NUT 2 2011-11_
22 5117314/1.40.516B 球铰接头总成 BALL ARTICULATION JOINT ASSEMBLY 1 2011-11_

23 10726914/10114 锁紧薄螺母 LOCKING THIN NUT 1 2011-11_

24 5142234/14 转向横拉杆合件 STEERING CROSS PULL ROD UNIT 1 2011-11_
3 5111572/1.63.584 油缸销 OIL CYLINDER PIN 1 2011-11_
4 GBT1152-M10X1 油杯 OIL CUP 2 2011-11_
7 JK-3X 环箍 Clip 2 2011-11_

8 5134221/22 转向油缸 STEERING OIL CYLINDER 1 2011-11_

9 JBT982-14 组合密封垫圈 COMBINED SEAL GASKET 4 2011-11_
9 JBT982-14 组合密封垫圈 COMBINED SEAL GASKET 4 2011-11_

392
 TD824-1F161F23K拖拉机

393
 TD824-1F161F23K拖拉机

1004-4TRT82-N02-16 前端驱动输入 FRONT END DRIVE INPUT

标号 代号 名称 数量 备注
No. Code Description Quantity Remark

1 T3115T051B 皮带轮 BELT WHEEL 1 2011-11_

2 T3241N001 止推块 THRUST BLOCK 1 2011-11_
3 T32186137 螺栓 BOLT 3 2011-11_

394
 TD824-1F161F23K拖拉机

395