Safety Data Sheet

Revision Number: 002.3 Issue date: 07/11/2014

1. PRODUCT AND COMPANY IDENTIFICATION

Product name: BONDERITE C-AK 1533 R ALKALINE IDH number: 596337
CLEANER known as PARCO
CLEANER 1533R
Product type: Cleaner
Restriction of Use: None identified Region: United States
Company address: Contact information:
Henkel Corporation Telephone: +1 (860) 571-5100
One Henkel Way MEDICAL EMERGENCY Phone: Poison Control Center
Rocky Hill, Connecticut 06067 1-877-671-4608 (toll free) or 1-303-592-1711
TRANSPORT EMERGENCY Phone: CHEMTREC
1-800-424-9300 (toll free) or 1-703-527-3887
Internet: www.henkelna.com

2. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
DANGER: HARMFUL IF SWALLOWED.
CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.

HAZARD CLASS HAZARD CATEGORY

ACUTE TOXICITY ORAL 4
SKIN CORROSION 1B
SERIOUS EYE DAMAGE 1

PICTOGRAM(S)

Precautionary Statements

Prevention: Do not breathe vapors, mist, or spray. Wash thoroughly after handling. Do not eat, drink or
smoke when using this product. Wear protective gloves, eye protection, and face protection.
Response: If SWALLOWED: Immediately call poison control or physician if you feel unwell. IF
SWALLOWED: Rinse mouth. Do NOT induce vomiting. If on skin (or hair): Take off immediately
all contaminated clothing. IF INHALED: Remove person to fresh air and keep comfortable for
breathing.
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if
present and easy to remove. Continue rinsing. Immediately call a poison control center or
physician. Wash contaminated clothing before reuse.
Storage: Store locked up.
Disposal: Dispose of contents and/or container according to Federal, State/Provincial and local
governmental regulations.

Classification complies with OSHA Hazard Communication Standard (29 CFR 1910.1200) and is consistent with the provisions of the
United Nations Globally Harmonized System of Classification and Labeling of Chemicals (GHS).

See Section 11 for additional toxicological information.

3. COMPOSITION / INFORMATION ON INGREDIENTS

IDH number: 596337 Product name: BONDERITE C-AK 1533 R ALKALINE CLEANER known as PARCO CLEANER 1533R
Page 1 of 6
Hazardous Component(s) CAS Number Percentage*
Potassium hydroxide 1310-58-3 10 - 30
Sodium hydroxide 1310-73-2 5 - 10
Sodium silcate 1344-09-8 5 - 10
Metaphosphoric acid, trisodium salt 7785-84-4 1-5

* Exact percentage is a trade secret. Concentration range is provided to assist users in providing appropriate protections.

4. FIRST AID MEASURES

Inhalation: If mist or vapor of this product is inhaled, remove person immediately to fresh
air. Seek medical attention if symptoms develop or persist.

Skin contact: Remove contaminated clothing and footwear. For skin contact, flush with large
amounts of water. Seek immediate medical attention.

Eye contact: In case of contact with the eyes, rinse immediately with plenty of water for 15
minutes, and seek immediate medical attention.

Ingestion: Get medical attention. DO NOT induce vomiting unless directed to do so by

medical personnel. Give one to two glasses of water or milk. Never give
anything by mouth to a victim who is unconscious or is having convulsions.

Symptoms: See Section 11.

Notes to physician: Treat symptomatically and supportively.

5. FIRE FIGHTING MEASURES

Extinguishing media: Use media appropriate for surrounding material.

Special firefighting procedures: Wear full protective clothing. Wear self-contained breathing apparatus.

Unusual fire or explosion hazards: This product is an aqueous mixture which will not burn.

Hazardous combustion products: Irritating and toxic gases or fumes may be released during a fire.

6. ACCIDENTAL RELEASE MEASURES

Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected
personnel.

Environmental precautions: Prevent further leakage or spillage if safe to do so. Wear appropriate personal
protective equipment. Do not allow product to enter sewer or waterways.

Clean-up methods: Absorb spill with inert material. Shovel material into appropriate container for
disposal. Dispose of according to Federal, State and local governmental
regulations.

IDH number: 596337 Product name: BONDERITE C-AK 1533 R ALKALINE CLEANER known as PARCO CLEANER 1533R
Page 2 of 6
 7. HANDLING AND STORAGE
Handling: Avoid contact with eyes, skin and clothing. Avoid breathing vapors or mists of
this product. Provide adequate ventilation. Wash thoroughly after handling.
For industrial use only. Do not take internally. NEVER ADD WATER TO
PRODUCT. For dilutions, add product slowly to water while stirring. Use
caution; heat may be generated.

Storage: For safe storage, store between 40 °F (4.4 °C) and 100 °F (37.8 °C)
Keep container tightly closed and in a cool, well-ventilated place away from
incompatible materials. If stored outside of this range, mix well before using.

For information on product shelf life, please review labels on container or check the Technical Data Sheet.

8. EXPOSURE CONTROLS / PERSONAL PROTECTION

Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure
controls and protective equipment for each task performed.

Hazardous Component(s) ACGIH TLV OSHA PEL AIHA WEEL OTHER

Potassium hydroxide 2 mg/m3 Ceiling None None None
Sodium hydroxide 2 mg/m3 Ceiling 2 mg/m3 PEL None None
Sodium silcate None None None None
Metaphosphoric acid, trisodium salt None None None None

Engineering controls: Provide local and general exhaust ventilation to effectively remove and
prevent buildup of any vapors or mists generated from the handling of this
product.

Respiratory protection: If ventilation is not sufficient to effectively prevent buildup of aerosols, mists or
vapors, appropriate NIOSH/MSHA respiratory protection must be provided.
Respirators should be selected by and used under the direction of a trained
health and safety professional following requirements found in OSHA's
respirator standard (29 CFR 1910.134) and ANSI's standard for respiratory
protection (Z88.2-1992). A written respiratory protection program, including
provisions for medical certification, training, fit testing, exposure assessments,
maintenance, inspection, cleaning, and convenient, sanitary storage must be
implemented. If concentrations are below the TLV and/or PEL, a NIOSH
approved disposable dust/mist respirator may be used for personal comfort.
For concentrations above the TLV and/or PEL but less than 10 times these
limits, a NIOSH approved half-facepiece respirator equipped with dust-mist
cartridges may be used. For concentrations greater than 10 times these limits,
consult the NIOSH respirator decision logic found in Publication No. 87-116 or
ANSI Z88.2-1992.

Eye/face protection: Wear chemical goggles; face shield (if splashing is possible).

Skin protection: Chemical resistant, impermeable gloves. The use of butyl rubber gloves is
recommended. Use of impervious apron and boots are recommended.

9. PHYSICAL AND CHEMICAL PROPERTIES

Physical state: Liquid
Color: Colorless
Odor: None
Odor threshold: Not available.
pH: > 13
Vapor pressure: Not determined
Boiling point/range: > 100 °C (> 212°F) calculated
Melting point/ range: Not determined
Specific gravity: 1.35 - 1.38 at 20 °C (68°F)
Vapor density: Not determined
Flash point: Not applicable
Flammable/Explosive limits - lower: Not applicable

IDH number: 596337 Product name: BONDERITE C-AK 1533 R ALKALINE CLEANER known as PARCO CLEANER 1533R
Page 3 of 6
 Flammable/Explosive limits - upper: Not applicable
Autoignition temperature: Not applicable
Evaporation rate: Not determined
Solubility in water: Complete
Partition coefficient (n-octanol/water): Not determined
VOC content: Not applicable
Viscosity: Not available.
Decomposition temperature: Not available.

10. STABILITY AND REACTIVITY

Stability: Stable at normal conditions.

Hazardous reactions: None under normal processing.

Hazardous decomposition Irritating and toxic gases or fumes may be released during a fire.
products:

Incompatible materials: Reacts with acids.

Reactivity: Not available.

Conditions to avoid: Keep away from heat, ignition sources and incompatible materials.

11. TOXICOLOGICAL INFORMATION

Relevant routes of exposure: Skin, Inhalation, Eyes

Potential Health Effects/Symptoms

Inhalation: Mists, vapors or liquid may cause severe irritation or burns.

Skin contact: Corrosive to the skin. Contact with the skin or mucous membranes may cause severe irritation
and burns.
Eye contact: This product is severely irritating to the eyes and may cause irreversible damage including
burns and blindness.
Ingestion: This product may produce corrosive damage to the gastrointestinal tract if it is swallowed.

Hazardous Component(s) LD50s and LC50s Immediate and Delayed Health Effects
Oral LD50 (RAT) = 273 mg/kg
Potassium hydroxide Corrosive, Irritant
Oral LD50 (RAT) = 1.23 g/kg
Sodium hydroxide None Irritant, Corrosive, Eyes
Oral LD50 (RAT) = 1,100 - 1,600 mg/kg
Sodium silcate Corrosive, Irritant
Oral LD50 (RAT) = 1.1 g/kg
Metaphosphoric acid, trisodium salt None Irritant, Metabolic

OSHA Carcinogen
Hazardous Component(s) NTP Carcinogen IARC Carcinogen
(Specifically Regulated)
Potassium hydroxide No No No
Sodium hydroxide No No No
Sodium silcate No No No
Metaphosphoric acid, trisodium salt No No No

12. ECOLOGICAL INFORMATION

Ecological information: No data available.

IDH number: 596337 Product name: BONDERITE C-AK 1533 R ALKALINE CLEANER known as PARCO CLEANER 1533R
Page 4 of 6
 13. DISPOSAL CONSIDERATIONS
Information provided is for unused product only.

Recommended method of disposal: Follow all local, state, federal and provincial regulations for disposal.

Hazardous waste number: This product, if discarded directly, would be a characteristic RCRA corrosive
waste (D002). Wastes must be tested using methods described in 40 CFR
Part 261 to determine if it meets applicable definitions of hazardous wastes.

14. TRANSPORT INFORMATION

The transport information provided in this section only applies to the material/formulation itself, and is not specific to any
package/configuration.

U.S. Department of Transportation Ground (49 CFR)

Proper shipping name: Corrosive liquid, basic, inorganic, n.o.s. (Potassium hydroxide, Sodium hydroxide)
Hazard class or division: 8
Identification number: UN 3266
Packing group: II
DOT Hazardous Substance(s): Potassium hydroxide, Sodium hydroxide

International Air Transportation (ICAO/IATA)

Proper shipping name: Corrosive liquid, basic, inorganic, n.o.s. (Potassium hydroxide, Sodium hydroxide)
Hazard class or division: 8
Identification number: UN 3266
Packing group: II

Water Transportation (IMO/IMDG)

Proper shipping name: CORROSIVE LIQUID, BASIC, INORGANIC, N.O.S. (Potassium hydroxide,
Sodium hydroxide)
Hazard class or division: 8
Identification number: UN 3266
Packing group: II

15. REGULATORY INFORMATION

United States Regulatory Information

TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act
Inventory.
TSCA 12 (b) Export Notification: None above reporting de minimis

CERCLA/SARA Section 302 EHS: None above reporting de minimis

CERCLA/SARA Section 311/312: Immediate Health
CERCLA/SARA Section 313: None above reporting de minimis
CERCLA Reportable quantity: Potassium hydroxide (CAS# 1310-58-3) 1,000 lbs. (454 kg)
Sodium hydroxide (CAS# 1310-73-2) 1,000 lbs. (454 kg)

California Proposition 65: No California Proposition 65 listed chemicals are known to be present.

Canada Regulatory Information

CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Canadian Domestic
Substances List.

16. OTHER INFORMATION

This safety data sheet contains changes from the previous version in sections: New Safety Data Sheet format.

Prepared by: Jennifer Mckay, Regulatory Affairs Specialist

Issue date: 07/11/2014

IDH number: 596337 Product name: BONDERITE C-AK 1533 R ALKALINE CLEANER known as PARCO CLEANER 1533R
Page 5 of 6
 DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel
Corporation and its affiliates (“Henkel”) does not assume responsibility for any results obtained by persons over whose methods
Henkel has no control. It is the user’s responsibility to determine the suitability of Henkel’s products or any production methods
mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and
persons against any hazards that may be involved in the handling and use of any Henkel’s products. In light of the foregoing,
Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular
purpose, arising from sale or use of Henkel’s products. Henkel further disclaims any liability for consequential or incidental damages
of any kind, including lost profits.

IDH number: 596337 Product name: BONDERITE C-AK 1533 R ALKALINE CLEANER known as PARCO CLEANER 1533R
Page 6 of 6