Test Instructions: - Mechanical

Test Instructions
- mechanical -
Xperia Mini Pro

SK17i, SK17a
1251-8385 Rev 1
 Sony Ericsson Mobile Communications AB – Company Internal
Test Instructions (mech)
CONTENTS
1 Pre-Test Preparations .................................................................... 4
1.1 Hardware............................................................................................... 4
1.1.1 Water indicator inspection.......................................................................... 4
1.1.2 Slider performance test............................................................................... 4
1.2 Software ................................................................................................ 5
1.2.1 Software update ........................................................................................... 5
2 Tests ................................................................................................ 6
2.1 Service Test Mode ................................................................................ 6
2.2 Service Tests ........................................................................................ 7
2.2.1 Keyboard & Switch ...................................................................................... 7
2.2.2 Touch Screen ............................................................................................... 7
2.2.3 Display .......................................................................................................... 7
2.2.4 LED/Illumination .......................................................................................... 8
2.2.5 Speaker......................................................................................................... 8
2.2.6 Stereo speaker ............................................................................................. 8
2.2.7 Earphone ...................................................................................................... 9
2.2.8 Microphone .................................................................................................. 9
2.2.9 Secondary Microphone ............................................................................... 9
2.2.10 Vibrator ....................................................................................................... 10
2.2.11 Camera ....................................................................................................... 10
2.2.12 Secondary Camera .................................................................................... 10
2.2.13 Flash LED ................................................................................................... 11
2.2.14 Bluetooth .................................................................................................... 11
2.2.15 WLAN .......................................................................................................... 11
2.2.16 GPS ............................................................................................................. 12
2.2.17 Compass .................................................................................................... 12
2.2.18 Accelerometer ............................................................................................ 12
2.2.19 Ambient Light Sensor ............................................................................... 13
2.2.20 Proximity switch ........................................................................................ 13
2.2.21 Pressure Sensor ........................................................................................ 14
2.2.22 Real time clock .......................................................................................... 14
2.2.23 Total call time............................................................................................. 14
2.2.24 External Memory........................................................................................ 15
2.2.25 Security ...................................................................................................... 15
2.2.26 FM radio...................................................................................................... 15
2.2.27 Battery test ................................................................................................. 16
2.2.28 Flip slider counter ..................................................................................... 17
2.2.29 Verify certificates ....................................................................................... 17
2.2.30 IrDA Test..................................................................................................... 17
2.2.31 HDMI Test ................................................................................................... 18
2.2.32 Connector Ground Test ............................................................................ 18
2.3 Manual Tests ...................................................................................... 19
2.3.1 SIM .............................................................................................................. 19
2.3.2 On/Off key test ........................................................................................... 19
2.3.3 Home key test ............................................................................................ 19
2.3.4 Charging via USB (Charger or Computer) .............................................. 20
1251-8385 Rev 1
 Sony Ericsson Mobile Communications AB – Company Internal 2(22)
2.3.5 Chat Camera .............................................................................................. 20
2.4 Network Test....................................................................................... 21
2.4.1 On-the-air call to mobile (no UMTS network available) .......................... 21
2.4.2 On-the-air call to mobile (UMTS network available) ............................... 21
3 Revision History ........................................................................... 22
For general information about test procedures, refer to

1220-1333: Generic Repair Manual - mechanical
1251-8385 Rev 1
1 Pre-Test Preparations
1.1 Hardware
1.1.1 Water indicator inspection
Before starting any tests the liquid intrusion indicator has to
be checked.
The indicator is located as shown in this picture after the
battery cover is removed.
If affected (red color) - handle the phone according to your
local directives.
If not affected by liquid, proceed to the ‘Pre-Test
Preparation’ below.
1.1.2 Slider performance test

1. Start up the phone with a fully charged battery and check
that the display operates normally.
2. If the display never gets illuminated or no text is
displayed, refer to 1251-8384.
3. When the display gets illuminated with text shown, wait

until the light goes off and then open or close the slider as
shown in the picture.
4. The display should now be reactivated.
5. If not, this indicates a problem with the slider sensor on
the PBA or the magnet in the Touch/Display Front Cover
Assy.
6. Replace the Touch/Display Front Cover Assy. If the
problem continues send the phone to higher level of
repair.
1251-8385 Rev 1
Pre-Test Preparations
1.2 Software
1.2.1 Software update
1.2.1.1 Software version verification
Check the software version of the phone for fault verification, you find latest improvements on the
support pages under the support news
http://www.sonyericsson.com/cws/marketingurlportal?pageid=key.SupportZone.Overview
• Start up the phone
• Note: Please make sure the phone is in call setup.
• Pressing keypad combination: *#*#7378423#*#*
• select ‘Service info’
• select ‘Software info’
• check the software file revisions and, if needed, update as described below
For more information, refer to 1220-1333: Generic Repair Manual - mechanical
1.2.1.2 Software version update
Mandatory first repair action!
Use the Micro USB to USB cable for this purpose!
Insert a fully charged battery, ensure the phone is powered off and proceed as follows:
• Open the Emma application and log in.
• Press and keep the ’Volume Down key’ on the phone, connect the phone to the USB cable and then
release the ’Volume Down key’.
• Select the appropriate service and follow the on-screen instructions.
1251-8385 Rev 1
2 Tests
2.1 Service Test Mode
Sony Ericsson
Sony Ericsson
Note: Please make sure the phone is in call setup when

1 2 3
pressing these touching keypads to get into the Service
menu! 4 5 6
Start up the phone and enter the service menus:
• press the keypad combination with the following order:
7 8 9
*#*#7378423#*#*
* 0 #
XPERIA
Sony Ericsson
Sony Ericsson
Service
• select ‘Service tests’ Service info
Service Settings
• select one of the tests and follow the test instructions as
Service test
described below
Customization Settings
• to stop the test and return to the ‘Service tests’ menu,
press the Back key
For more information, refer to
1220-1333: Generic Repair Manual - mechanical
XPERIA
The pictures to follow will show a simplified basic phone for a general visualization of the
service tests!
1251-8385 Rev 1
Tests
2.2 Service Tests
2.2.1 Keyboard & Switch
Text Note: The Home Key and On/Off key is not part of
the keyboard test, which are in Manual tests.
To return to the Service Test Menu, wait 8 seconds.
Press all keys on the:
-Back key
-Menu key
-Auto Focus/Camera key
-Volume up key
-Volume down key
-All Qwerty keys
Sony Ericsson
Sony Ericsson
Touch Screen
2.2.2 Touch Screen

Move your finger across the Display, a line will be drawn as
you touch the Display.
Press Back key to return to Service Test Menu.
XPERIA
2.2.3 Display
Sony Ericsson
Sony Ericsson
Minor variations in display brightness and color may
occur between phones.
There may be tiny bright dots on the display, so called
defective pixels and occur when individual dots have
malfunctioned and cannot be adjusted.
Two defective pixels are considered to be acceptable.
Touch display using finger, the display will show six test
patterns of White, Black, Red, Green, Blue and Rainbow
colors on full screen.
Make sure that there are no missing segments and that the
colors and contrast are OK. XPERIA
1251-8385 Rev 1
Tests: Service Tests
2.2.4 LED/Illumination Sony Ericsson

Sony Ericsson
Check that the:

- Display Backlight illumination goes from low to high
strength back to low again.
- Back and Menu keys Backlight illumination goes from low LED/illumination
to high strength back to low again.
- Notification LED on top left corner is changed, showing
four colors in the sequence; Red, Green, Blue, and Off.
- All Qwerty keys Backlight illumination goes from low to
high strength back to low again.
XPERIA
2.2.5 Speaker
Do not hold the phone close to your ear during this test!
Make sure that the sound from the speaker port on the
middle bottom back side of the phone is emitted loud and
clear and that the test include maximum volume.
Press Volume up/Volume down key to adjust speaker

volume.
2.2.6 Stereo speaker

N/A. This test is not applicable for this product.
1251-8385 Rev 1
Sony Ericsson
2.2.7 Earphone Sony Ericsson
Earphone
Media Volume
Do not hold the phone close to your ear during this test!
Make sure that the sound from the Earphone port on the top
of the phone is emitted loud and clear and that the test
include maximum volume. Earphone
Press Volume up/Volume down key to adjust earphone

volume.

XPERIA
2.2.8 Microphone
The previous test ‘Speaker’ should have been
successfully carried out before doing this test!
The phone will start to record and after approximately
ten seconds the sound is played back through the Speaker.
Speak into the microphone during the ‘Microphone
Recording’ phase.
Check the quality by listening to the recording from the
Speaker during the ‘Playing recorded sound’ phase at
maximum volume.
2.2.9 Secondary Microphone

The previous test ‘Speaker’ should have been Sony Ericsson
successfully carried out before doing this test! Media Volume
The phone will start to record and after approximately

ten seconds the sound is played back through the Speaker.
Speak into the microphone during the ‘Microphone 2nd Microphone test:
Recording’ phase. Microphone recording
Check the quality by listening to the recording from the

Speaker during the ‘Playing recorded sound’ phase at
maximum volume.
XPERIA
1251-8385 Rev 1
Sony Ericsson
Sony Ericsson
2.2.10 Vibrator Test vibrating alert.

Enter time to vibrate in ms
and press Menu key or side keys.
Press the Menu key or Side keys to start the vibrator test. 3000
XPERIA
XPERIA
2.2.11 Camera
Minor variations in image appearance may occur
between phones, but is not uncommon and should not
be regarded as an indication of a defective camera
module!
Aim the camera (located back of the phone) at an object and
check the quality of the image shown in the display.
Press the ‘Camera’ key to preview the photo’s quality about
auto focus.
Photos is taken but not saved during this test!
2.2.12 Secondary Camera

Minor variations in image appearance may occur
module!
Aim the camera (located front upper right of the phone) at an
object and check the quality of the image shown in the
display.
1251-8385 Rev 1
2.2.13 Flash LED

Check the Flash LED at the back side of phone whether it is
turned on.
2.2.14 Bluetooth Sony Ericsson

Bluetooth
During this test, the distance between the phone and Enable Bluetooth OK
Searching
Devices found
Test Complete
the target Bluetooth device must be 1.5 to 5 meters!

Distance:
Make sure the target Bluetooth device is enabled and 1.5 to 5meters
visible always!
XPERIA
The Bluetooth test will be done in following sequences:

Sony Ericsson
Step 1: Enable Bluetooth; wait 4-5 seconds, shows OK; Bluetooth
Enable Bluetooth OK
Step 2: Searching; Searching
Devices found
Step 3: Device Found list; Test Complete
Step 4: Select the Target Bluetooth Device, and Type PIN

code to Pair;
Step 5: Type the Pairing PIN code on Target Bluetooth
Device also, when succeeded, it shows “Test
Complete”. XPERIA
2.2.15 WLAN
Sony Ericsson
Sony Ericsson
Make sure there’s WLAN network before performing this WLAN
test.
Enable WLAN OK
The WLAN test will be done in following sequences: Searching
Access points found
Step 1: Enable WLAN; wait 4-5 seconds, shows OK; Connect to …..
Connection successfully
Step 2: Searching; setup
Enter WEB address to
Step 3: Access points Found list; connect to
Connect to http:// ….
Step 4: Select the Target WLAN network, and Type Test Complete
Password to get connection;
Step 5: Enter a web address (ex. google.com)
Step 6: When Connection succeeded, it shows “Test
Complete”. XPERIA
1251-8385 Rev 1
Sony Ericsson
Sony Ericsson
2.2.16 GPS GPS
This test should be finished in the outdoor condition GPS Location Test
and it will take several minutes to search satellite. GPS Test Settings
Test with local SIM inserted will shorten the time of Purge assistance data
searching satellite.
Enter GPS Location Test, wait some time to get GPS
location data.

For GPS testing, refer to1220-1333: Generic Repair
Manual - mechanical XPERIA
Sony Ericsson
Sony Ericsson
Compass
Yaw: 250.2
Pitch: 4.1
Roll: 3.5
2.2.17 Compass (Yaw: 0=North 90=East 180=South 270=West)
Do calibration with hand movements as shown in the phone, Do calibration in the following procedures
and then check

The actual direction with measured value.
(Yaw:0=North, 90=East, 180=South, 270=West)
XPERIA
Sony Ericsson
Sony Ericsson
Accelerometer
2.2.18 Accelerometer X: 0,1234
Y: 6,7890
Z: 0,1234
The accelerometer test displays the actual position of the
phone as a 3D coordinate X:Y:Z
XPERIA
1251-8385 Rev 1
+Y Front -Y
-Y LEFT SIDE VIEW +Y

By tilting the phone in various directions, the X: Y: Z values
will change in size and polarity depending on angle and +Z -Z
direction as shown in the adjacent picture.

Check by tilting the phone that the X: Y: Z values shown in
the display are in accordance with the tilting shown in the -X
Front
+X
picture. LEFT SIDE

Front
VIEW
+X BOTTOM VIEW - X
-Z +Z
Sony Ericsson
Sony Ericsson
2.2.19 Ambient Light Sensor

The Ambient light test states a value. Look that the value
Ambient Light Sensor
should be higher when the Window gets more light and Value:45
should decrease when the window gets less light.
XPERIA
2.2.20 Proximity switch Sony Ericsson

Sony Ericsson
The previous test ‘Speaker’ should have been
successfully carried out before doing this test!
Make sure the phone is not in ‘silent mode’ before
performing this test. Proximity switch
When entering into the test, the screen shows “Proximity ON

switch OFF” and a tone is emitted.
Once your finger cover the proximity switch area (on the left
side of the receiver), the screen will show “Proximity switch
ON” with a different type of tone.
XPERIA
1251-8385 Rev 1
Sony Ericsson
GPS
Compass
Accelerometer
2.2.21 Pressure Sensor Ambient Light Sensor
N/A. This test is not applicable for this product. Proximity Switch
Pressure Sensor
Pressure Sensor Unvailable
Real time clock
Total call time

XPERIA
Sony Ericsson
Sony Ericsson
2.2.22 Real time clock

Real time clock
During the actual test the text ‘Real time clock test’ is
displayed, then followed by a message stating whether the OK
test was OK or not.
XPERIA
Sony Ericsson
Sony Ericsson
2.2.23 Total call time

Total call time
The total call time is displayed in the format HH:MM:SS
00:01:07
(hours: minutes: seconds).
XPERIA
1251-8385 Rev 1
Sony Ericsson
Sony Ericsson
2.2.24 External Memory

A memory card should be inserted in the phone before Memory card status:
the start of this test!
Inserted
The phone should detect that the memory card is inserted.
XPERIA
Sony Ericsson
Sony Ericsson
SEMC_TEST [Key OK][Active]

VIACCESS_TEST [Key OK][Not active]
MARLIN_TEST [Key OK][Active]
2.2.25 Security
The DRM keys are shown in the display.
There may be some different content showed based on the
different market software versions.
XPERIA
2.2.26 FM radio
Verify that the phone can detect a radio station:
Connect a headset and then set your local radio station in
Hz!
Secure that the reception and sound quality is normal.
1251-8385 Rev 1
Sony Ericsson
Sony Ericsson
Start level(%): -1
Curr level(%): 36
2.2.27 Battery test Min Level(%)
Voltage(mV):
70
3906
Temp(C): 33.0
Plug Type: None
Test is intended to verify the condition of the battery when Status: Discharging
Batt type: Li-Poly
the consumer have complain about charging or standby time Health: GOOD
Time:
before trying to replace the battery. Pow cons(mA): 0.0
New battery(mAh): 1200
When you enter the battery test menu, you are prompted to Result: Plug in charger
insert charger in green text at the end.

Battery test will take several hours.
XPERIA
Sony Ericsson
Start level(%): -1
Curr level(%): 71
Min Level(%) 70
Voltage(mV): 3998
Temp(C): 34.0
Plug Type: Charger
Status: Charging
Connect a Sony Ericsson charger (to secure correct Batt type:
Health:
Li-Poly
GOOD
result). Time:
Pow cons(mA): 0.0
Result: Charging...
XPERIA
Sony Ericsson
Sony Ericsson
Start level(%): -1
Curr level(%): 100
Min Level(%) 70
Voltage(mV): 4098
When the test is over, one of the following results will be Temp(C): 35.0
Plug Type: None
shown in the display: Status: Discharging
Batt type: Li-Poly
Green backlight and say Good if the battery is ok. Health: GOOD
Time:
Red backlight and say Bad if the battery is not ok. Pow cons(mA): 0.0
Result: Plug in charger
Press Back key and return to Service Test Menu.
XPERIA
1251-8385 Rev 1
Sony Ericsson
Flip slider counter: 8
2.2.28 Flip slider counter

The total slide times is displayed.
When you slide the phone, the number will be added.
XPERIA
2.2.29 Verify certificates

N/A.
Sony Ericsson
External Memory
Security
2.2.30 IrDA Test FM Radio
Battery test
Flip slider counter
Verify certificates
IrDA Test
IrDA Test app doesn’t exist
HDMI Test
XPERIA
1251-8385 Rev 1
Sony Ericsson
HDMI Test
HDMI On
HDMI Settings
2.2.31 HDMI Test
XPERIA
Sony Ericsson
Security
FM Radio
2.2.32 Connector Ground Test Battery test
N/A. This test is not applicable for this product. Flip slider counter
Verify certificates
IrDA Test
HDMI Test
Ground Connector Unvailable
Connector Ground Test

XPERIA
1251-8385 Rev 1
Tests
2.3 Manual Tests
2.3.1 SIM
Sony
SonyEricsson
Ericsson
Verify that the phone can detect a SIM card:
• Insert a SIM card, install a battery and start the phone. Operator name
• If the SIM card is detected by the phone, the start-up Notifications
procedure will continue.

• Pull down the Status Bar (put your finger next to the
receiver and drag down the menu from the Status Bar)
• to see SIM card operator name.
• The SIM card operator name will displayed above Time
clock when phone is in Lock status.
• If not detected, the message ‘No SIM Card in phone’ will XPERIA
be displayed above Time clock when phone is in Lock
status.
•
Sony Ericsson
Sony Ericsson
2.3.2 On/Off key test 15:35

Press the On/Off key long time to turn phone On or Off. 2010-03-15
Press the On/Off key a short time to enter Sleep mode or to
wake it up from Sleep mode.
XPERIA
Sony Ericsson
2.3.3 Home key test

Whatever the phone shows now during operation, Press
Home key and then phone will go back to the Stand by 15:35
screen directly. 2010-03-15
• When phone is in Sleep mode, Press Home key and the

Phone will light up.
XPERIA
1251-8385 Rev 1
Tests: Manual Tests
2.3.4 Charging via USB Sony Ericsson
(Charger or Computer)
Verify that the phone can charge the battery via a USB port:
Connect your phone
Update phone and manage your content
Ensure that no computer application, such as PC Suite
Install PC Companion
or Emma, is active! Install on your computer for phone updates
and media transfer
• Insert a battery but do not start the phone Charge the phone
• Connect a USB cable from a computer (or charger) to the

system connector. The phone will turn on automatically;
• Verify that the phone is being charged by red Notification
LED and Battery icon;
Remove the USB cable from the system connector and XPERIA
verify that Notification LED and Battery icon no longer

indicate.
2.3.5 Chat Camera SCN

AUTO
Minor variations in image appearance may occur 5M

module!
• Press Camera key to enter camera mode
• Press the third icon to change to chat camera
Aim the camera (located in front upper right of the phone) at
an object and check the quality of the image shown in the
display.
1251-8385 Rev 1
Tests
2.4 Network Test
This test can only be performed if the phone has got an activated SIM/USIM card (no Test
SIM/USIM) and an available network signal!
There are two versions of the test depending on whether a UMTS network is available or not!
If a UMTS network is available, the network test has to be done separately for GSM and UMTS!
2.4.1 On-the-air call to mobile (no UMTS network available)

To verify the radio functions (GSM) of the phone, follow the ‘2.4.1.1 Procedure’ below
2.4.1.1 Procedure
1. Set up a call from a landline phone (PSTN).
2. Check that there is a ring signal.
3. Check that the display backlight illuminates.
4. Answer the call and check the sound quality in both
phones.
5. Adjust the volume up and down with the side keys and
verify that the sound level is altered.
6. End the call and check that the elapsed time is displayed
and that the termination is done in a proper way.
2.4.2 On-the-air call to mobile (UMTS network available)

GSM
Go to the phone menu and set:
Press Menu keySettings Wireless controls Mobile Networks Network mode GSM only
To verify the radio functions (GSM) of the phone, follow the ‘2.4.1.1 Procedure’ above.
UMTS
Go to the phone menu and set:
Press Menu keySettings Wireless controls Mobile Networks Network mode WCDMA only
Switch off the phone and then start it up again to enable search for an available UMTS signal.
Ensure that the UMTS/3G icon now is visible at the top of the display.
To verify the radio functions (UMTS) of the phone, follow the ‘2.4.1.1 Procedure’ above.
1251-8385 Rev 1
3 Revision History
Rev. Date Changes / Comments
1 2011-Jul-12 Initial release
1251-8385 Rev 1

Test Instructions: - Mechanical

Uploaded by

Copyright:

Available Formats

Test Instructions: - Mechanical

Uploaded by

Document Information

Original Description:

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Test Instructions: - Mechanical

Uploaded by

Copyright:

Available Formats

Test Instructions

Xperia Mini Pro

For general information about test procedures, refer to

1.1.2 Slider performance test

3. When the display gets illuminated with text shown, wait

Note: Please make sure the phone is in call setup when

• select ‘Service tests’ Service info

2.2.2 Touch Screen

Press Back key to return to Service Test Menu.

Press Back key to return to Service Test Menu.

2.2.4 LED/Illumination Sony Ericsson

Check that the:

Press Back key to return to Service Test Menu.

Press Volume up/Volume down key to adjust speaker

Press Back key to return to Service Test Menu.

2.2.6 Stereo speaker

Press Volume up/Volume down key to adjust earphone

Press Back key to return to Service Test Menu.

Press Back key to return to Service Test Menu.

2.2.9 Secondary Microphone

successfully carried out before doing this test! Media Volume

The phone will start to record and after approximately

Recording’ phase. Microphone recording

Check the quality by listening to the recording from the

Press Back key to return to Service Test Menu.

2.2.10 Vibrator Test vibrating alert.

Press Back key to return to Service Test Menu.

Press Back key to return to Service Test Menu.

2.2.12 Secondary Camera

Press Back key to return to Service Test Menu.

2.2.13 Flash LED

Press Back key to return to Service Test Menu.

2.2.14 Bluetooth Sony Ericsson

the target Bluetooth device must be 1.5 to 5 meters!

The Bluetooth test will be done in following sequences:

Step 1: Enable Bluetooth; wait 4-5 seconds, shows OK; Bluetooth

Step 4: Select the Target Bluetooth Device, and Type PIN

Press Back key to return to Service Test Menu.

Press Back key to return to Service Test Menu.

2.2.16 GPS GPS

Press Back key to return to Service Test Menu.

2.2.17 Compass (Yaw: 0=North 90=East 180=South 270=West)

and then check

Press Back key to return to Service Test Menu.

-Y LEFT SIDE VIEW +Y

direction as shown in the adjacent picture.

picture. LEFT SIDE

Press Back key to return to Service Test Menu.

2.2.19 Ambient Light Sensor

Press Back key to return to Service Test Menu.

2.2.20 Proximity switch Sony Ericsson

When entering into the test, the screen shows “Proximity ON

Press Back key to return to Service Test Menu.

2.2.21 Pressure Sensor Ambient Light Sensor

Real time clock

Total call time

2.2.22 Real time clock

test was OK or not.