Electric Car User Manual

The owner’s manual contains important safety

information as well as assembly, use and maintenance
instructions.

The Ride-on Car must be assembled by an adult who

has read and understands the instructions in this
manual.

Keep the package away from children and dispose of

properly before use.

Keep this manual for future reference.

Specifications
Battery 6V 4.5Ah Sealed Lead Acid
Motor 2 x 6V, 15W
Charger Input:220-240V AC, Output 6VDC 500mA
Maximum load 25Kg
Charge/Run time 8-12 hour charge, Approximately 1 hour run
Speed 3-5km/h
Age 37-96 months
Remote control battery 2 x 1.5V AAA
Remote distance 15m ±5m
Before Assembly

WARNING!
• CHOKING HAZARD - Small parts. Not suitable for children
under 36 months.
The product contains small parts, keep children away when
assembling.
• ADULT ASSEMBLY REQUIRED.
• Always remove protective material and poly bags and dispose
before assembly.
• Make sure that the power switch is turned “OFF” before
assembling the ride-on.
• Before first time use, charge the battery for at least 8 to 10
hours
• Assembly tools required:
Screwdriver (not included)

Battery Information
● Non-rechargeable batteries are not to be recharged.
● Rechargeable batteries are to be removed from the toy before
being charged.
● Rechargeable batteries are only to be charged under adult
supervision.
● Different types of batteries or new and used batteries are not
to be mixed.
● Batteries are to be inserted with the correct polarity.
● Exhausted batteries are to be removed from the toy.
● The supply terminals are not to be short-circuited.
Assembly
1) Front casters: Locate and
secure with 4*16mm screws.
2) Rear axle: Take the springs
and black bushings from the
assembly pack. Insert the
spring and black bushing to the
car body. Remove the motor
transport screws and swing the
motors in to position. Slide the
rear axle through the motor, car
body, over the top of the black
bushings and motor/wheel on
the opposite side. Secure each
side with a washer and locking
nut.

Rear body. Take the rear body

section and push it in to place
over the rear of the car until you
hear a 'click'.

Remote Control batteries.

Remove the cover screw and
battery cover. Insert 2 x AAA
1.5V batteries, observing the
polarity. Replace the cover and
securing screw.
Steering wheel. Take the
steering wheel and locate the
black wiring connectors on the
steering wheel and car. Push
the connectors together until
they are firmly held in place.
Push the steering wheel on to
the car body and secure in
place with the nut and bolt.

With the steering wheel in

place, take four 4*16mm screws
from the assembly pack and
secure the dashboard in place.
 Take the windscreen piece.
Locate in place at the front of
the car and push down until you
hear a click.
Take the mirrors and identify left
and right, push them in to place
on the car body until you hear a
click.

IMPORTANT:
The car battery is not connected
for transport. Locate the battery
under the seat. Take the loose
red and black wires and press
firmly on to the red and black
battery terminals respectively,
making sure of a good, firm,
metal to metal contact.

Charge the car by inserting the

charger plug in to the charge
socket on the car, and plugging
the charger unit in to a wall
socket. The battery will begin
charging.

To use the car, turn it on with the power switch.

Use the handles on the steering wheel to operate the motors in
forwards and reverse.
To use the remote control, switch the car off. Hold down the 'M'
button on the remote control, and then turn the car on at the
power switch. The remote is now paired and ready to use. To
disable all drive motors, press the 'P' button. The light on the
remote will flash, indicating that all drive functions are disabled.
Press the 'P' button again to re-enable drive.
Charging
• PREVENT FIRE AND ELECTRIC SHOCK:
- Use the only rechargeable battery and charger supplied with your vehicle.
NEVER substitute the battery or the charger with another brand. Using
another battery or charger may cause a fire or explosion.
- Do not use the battery or charger for any other product. Overheating, fire or
explosion could occur.
- NEVER modify the electric circuit system. Tampering with the electric
system may cause a shock, fire or explosion or may permanently damage
the system.
- Do not allow direct contact between battery terminals. Fire or explosion can
occur.
- Do not allow any type of liquid on the battery or its components.
- Explosive gasses are created during charging. Do not charge near heat or
flammable materials. Charge the battery in a well-ventilated area ONLY.
- NEVER pick up the battery by the wires or charger. Damage can occur to
the battery and may cause a fire. Pick up the battery by the case ONLY.
- Charge the battery in a dry area ONLY.
• Battery posts, terminals and related accessories contain lead and lead
compounds, chemicals known to the State of California to cause cancer and
reproductive harm. Wash hands after handling.
• Do not open the battery. Battery contains lead acid and other materials that
are toxic and corrosive.
• Do not open the charger. Exposed wiring and circuitry inside case may
cause electric shock.
• Only adults may handle or charge the battery. NEVER allow child to handle
or charge the
battery. Battery is heavy and contains lead acid (electrolyte).
• Do not drop the battery. Permanent damage to the battery could occur or
cause serious injury.
• Before charging the battery, check for wear or damage to the battery,
charger, its supply cord and the connectors. DO NOT charge the battery if
any damage to parts has occurred.
• Do not allow the battery to drain completely. Recharge the battery after
each use or once a month if not used regularly.
• Do not charge battery upside down.
• Always secure the battery with the bracket. Battery can fall out and injure a
child if vehicle tips over.
• The POWER SWITCH must be turned in OFF position when charging.
• Before the first use, you should charge the battery for 4-6 hours. Do not
recharge the battery for more than 10 hours for first use.
• When the vehicle begins to run slowly, recharge the battery.
• After each use or once a month minimum recharge time as 8 to 12 hours,
less than 20 hours at most.
Battery replacement & Fuse
The battery features a thermal fuse with a rest fuse that will automatically trip
and cut all power to the vehicle if the motor, electric system or battery is
overloaded. The fuse will reset and power will be restored after the unit is
turned OFF for 20 seconds and then turned ON again. If the thermal fuse
trips repeatedly during normal use, the vehicle may need
repair. Contact your supplier.
To avoid losing power, follow these guidelines:
● Do not overload the vehicle.
● Do not tow anything behind the vehicle.
● Do not drive up steep slopes.
● Do not drive into fixed objects, which may cause the wheels to spin,
causing the motor to overheat.
● Do not drive in very hot weather, components may overheat.
● Do not allow water or other liquids to come in contact with the battery or
other electric components.
● Do not tamper with the electric system. Doing so may create a short,
causing the fuse to trip.
Battery Replacement and Disposal
The battery will eventually lose the ability to hold a charge. Depending on the
amount of use, and varying conditions, the battery should operate for one to
three years. Follow these steps to replace and dispose the battery:
1. Remove the car seat.
2. Disconnect the battery connectors.
3. Remove the battery bracket.
4. Remove the battery cover.
5. Carefully lift the battery.
● Depending on the condition of the battery (i.e.: leakage) you may want to
wear protective gloves before removal.
● Do not lift the battery by its connectors or cables.
6. Place the dead battery in a plastic bag.
Important! Recycle the dead battery responsibly. The battery contains lead
acid (electrolyte) and must be disposed of properly and legally. It is illegal in
most areas to incinerate lead acid batteries or dispose of them in landfills.
Take it to an approved lead acid battery recycler, such as local automotive
battery retailer.
Do not throw the battery away with your regular household waste!
7. Replace the battery and reconnect the connectors.
8. Replace the metal battery bracket.
9. Replace the seat.
Safety
WARNING!
PREVENT INJURIES AND DEATHS:
• NEVER LEAVE CHILD UNATTENDED. DIRECT ADULT
SUPERVISION IS REQUIRED. Always keep child in view when
child is in vehicle.
• This toy should be used with caution since skill is required to
avoid falls or collisions causing injury to the user or third parties.
• Protective equipment should be worn.
• Never use in roadways, near cars, on or near steep inclines or
steps, swimming pools or other bodies of water.
• Always wear shoes.
• Always sit on the seat.
• Not to be used in traffic.
• This toy is unsuitable for children under 36 months due to its
maximum speed; Maximum user weight is 25 kgs.
• This toy has no brake.

Rules for Safe Riding

• This vehicle has adjustable play seat belts. Please instruct

children how to tie the safety belt before using, guarantee their
security.
• Keep Children within Safe Riding Areas:
- Never use in roadway, near motor vehicles, on lawn space, on
or near steep inclines or steps, swimming pools or other bodies
of water;
• Use the toy only on flat surfaces. Such as inside your house,
garden or playground.
• Never use in the dark. A child could encounter unexpected
obstacles and have an accident. Operate the vehicle only in the
daytime or a well-lit area.
• It is prohibited to change the circuit or add other electric parts
• Inspect wires and connections of the vehicle periodically.
• Do not let any child touch the wheels or be near them when
the car is moving.
Troubleshooting
Problem Possible cause Solution
Vehicle does not run Battery low on power Recharge battery
Thermal fuse has tripped Wait 10-15 seconds and retry
Battery connections loose Check battery for loose wires
Battery is dead Replace battery
Electrical system is damaged Contact supplier
Motor is damaged Contact supplier
Vehicle does not run for very Battery under-charged Check battery connections
long and fully charge
Battery is old Replace battery
Vehicle runs slow Battery low on power Recharge battery
Battery is old Replace battery
Vehicle is over-loaded Reduce weight on vehicle.
Maximum weight is 25Kg
Vehicle is being used in harsh Vehicle is not suitable for use
conditions in temperatures less than -5
degrees C
Vehicle needs pushing to Poor contact on battery or Check battery and motor
drive motor wires connections
'Dead spot' on motor Contact supplier
Difficult to shift from forwards Attempting to change gear Stop the vehicle before
to reverse whilst the car is moving changing gear
Loud grinding sound from Motor or gearbox damage Contact supplier
motors
Battery will not recharge Battery connector loose Re-check battery connections
for firm, secure contact
Charger not plugged in Check wall outlet
Charger not working Contact supplier
Charger warm when charging This is normal
Battery warm or slightly noisy This is normal
when charging

Please read the troubleshooting guide above

before contacting your supplier.
Maintenance
• It is parents' responsibility to check main parts of the toy
before using, Must regularly examine for potential
hazard, such as the battery, charge,cable or cord, plug,
screws are fastening enclosure of other parts and that in
the event of such damage, the toy must not be used until
that damage had been properly
removed.
• Make sure the plastic parts of the vehicle are not
cracked or broken.
• Occasionally use a lightweight oil to lubricate moving
parts such as wheels.
• Park the vehicle indoors or cover it with a tarp to protect
it from wet weather.
• Keep the vehicle away from sources of heat, such as
stoves and heaters. Plastic parts may melt.
• Recharge the battery after each use. Only an adult can
handle the battery.
• Recharge the battery at least once a month when the
vehicle is not being used.
• Do not wash the vehicle with a hose. Do not wash the
vehicle with soap and water. Do not drive the vehicle in
rainy or snowy weather. Water will damage the motor,
electric system and battery.
• Clean the vehicle with a soft, dry cloth. To restore shine
to plastic parts, use a non-wax furniture polish. Do not
use car wax. Do not use abrasive cleaners.
• Do not drive the vehicle in loose dirt, sand or fine gravel
which could damage the moving parts, motors or the
electric system.
• When not using, all the electrical source should be turn
off. Turn off the power switch and disconnect the battery
connection.
Packing List
• Car body
• Steering wheel
• Seat
• 2 x Rear wheel
• Charger
• User Manual
• Remote control
• Assembly pack, including 2 x springs, 2 x bushings,
screws

Importer:
Tigris International Wholesale Limited
Unit 1, Northbrook Farm
Micheldever
Hampshire
SO21 3AJ

Item code: HL1068

This product is suitable for:

ASTM F963; GB6675; EN71 and EN62115 standard.