Worldwide

www.tyco-fire.com
Contacts

DV-5 Deluge Valve, Diaphragm Style,

1-1/2 thru 8 Inch (DN40 thru DN200),
Deluge System — Electric Actuation
General
Description
The DV-5 Deluge Valve (described in
Technical Data Sheet TFP1305) is a
diaphragm style valve that depends
upon water pressure in the Diaphragm
Chamber to hold the Diaphragm closed
against the water supply pressure.
When the DV-5 Valve is set for service,
the Diaphragm Chamber is pressurized
through the trim connections from the
inlet side of the system’s main con-
trol valve, for example an O.S.&Y. gate
valve or butterfly valve (Ref. Figures 1
and 4).
Operation of an electrical device such
as a heat sensitive thermostat, smoke
detector, or electrical manual control
station signals the Deluge Valve Re- NOTICE
leasing Panel to energize the Solenoid The DV-5 Deluge Valve with Electric
Valve. In turn, the energized Solenoid Actuation Trim described herein must
Valve opens to release water from the be installed and maintained in compli-
Diaphragm Chamber faster than it can ance with this document, as well as
be replenished through the 1/8 inch with the applicable standards of the
(3,2 mm) restriction provided by the National Fire Protection Association, in
Model ASV-1 Automatic Shut-Off Valve addition to the standards of any other
in the diaphragm supply connections authorities having jurisdiction. Failure
(Item 5 - Fig. 3A and 5, also described to do so may impair the performance
in Technical Data Sheet TFP1384). This of these devices.
results in a rapid pressure drop in the The owner is responsible for main-
Diaphragm Chamber and the force taining their fire protection system
differential applied through the Dia- and devices in proper operating con-
phragm that holds it in the set position dition. Contact the installing contrac-
is reduced below the valve trip point. tor or product manufacturer with any
The water supply pressure then forces questions.
the Diaphragm open permitting water
to flow into the system piping, as well
as through the Alarm Port to actuate
the system alarms.
As water flows into the system, the pi-
lot chamber of the Model ASV-1 Auto-
matic Shut-Off Valve (Item 5 - Fig. 3A
and 5) becomes pressurized and the
ASV-1 automatically shuts off the di-
aphragm chamber supply flow to the
DV-5 Diaphragm Chamber. Shutting
off the diaphragm chamber supply flow
prevents the DV-5 Diaphragm Chamber
from becoming re-pressurized, there-
by preventing inadvertent closing of the
DV-5 during a fire (as may be the case
should the Solenoid Valve become de-
energized after its initial operation).

Page 1 of 14 OCTOBER 2014 TFP1320

TFP1320
Page 2 of 14

13

5
6

11

14

7
8

3
9

15
2 4

1 - DV-5 Deluge Valve 7 - Water Supply Pressure Gauge 12 - Waterflow Pressure Alarm Switch
2 - Main Control Valve (N.O.) 8 - Diaphragm Chamber Pressure (Shown at Rear of Valve)
3 - Diaphragm Chamber Supply Gauge 13 - Water Motor Alarm (Optional)
Control Valve (N.O.) 9 - System Drain Valve (N.C.) 14 - Solenoid Valve
4 - Local Manual Control Station 10 - Main Drain Valve (N.C.) 15 - Deluge Valve Releasing Panel
5 - Open Nozzles or Sprinklers (Shown at Rear of Valve)
6 - Heat Detectors, Smoke Detectors, 11 - Diaphragm Chamber Automatic
etc. (Fire Detection) Shut-Off Valve

FIGURE 1 (1 OF 2)
SYSTEM SCHEMATIC (FRONT VIEW)
ELECTRIC ACTUATION
 TFP1320
Page 3 of 14

15 13

11

14

12

9 3

10
1

1 - DV-5 Deluge Valve 7 - Water Supply Pressure Gauge 13 - Water Motor Alarm (Optional)
2 - Main Control Valve (N.O.) (Shown at Front of Valve) 14 - Solenoid Valve
3 - Diaphragm Chamber Supply 8 - Diaphragm Chamber Pressure 15 - Deluge Valve Releasing Panel
Control Valve (N.O.) Gauge (Shown at Front of Valve)
4 - Local Manual Control Station 9 - System Drain Valve (N.C.)
(Shown at Front of Valve) 10 - Main Drain Valve (N.C.)
5 - Open Nozzles or Sprinklers 11 - Diaphragm Chamber Automatic
6 - Heat Detectors, Smoke Detectors, Shut-Off Valve
etc. (Fire Detection) 12 - Waterflow Pressure Alarm Switch

FIGURE 1 (2 OF 2)
SYSTEM SCHEMATIC (REAR VIEW)
ELECTRIC ACTUATION
TFP1320
Page 4 of 14

WATERFLOW
tion intended to energize the Solenoid
PRESSURE DELUGE
Valve to open. After the ten minute du-
ALARM ELECTRIC ration, at which point should the Sole-
SWITCH ACTUATION noid Valve become de-energized and
TRIM close (especially while operating under
battery back-up), the Automatic Shut-
Off Valve will have already automatical-
NOTES: ly closed, thereby preventing the DV-5
1. SEE FIGURE 3, PER VALVE SIZE Diaphragm Chamber from becoming
AS APPLICABLE, FOR TRIM re-pressurized, and preventing an in-
ARRANGEMENT WITH BILL OF advertent closing of the DV-5 during a
MATERIALS AND COMPONENT fire event.
PART NUMBERS.

DV-5
2. TRIM SHOWN FULLY ASSEMBLED;
COMPONENTS SUCH AS GAUGES
AND SWITCHES MAY REQUIRE
Materials of
DELUGE
VALVE
ASSEMBLY IN TRIM AT VALVE
INSTALLATION.
Construction
NOTES: The galvanized or brass nip-
SYSTEM ples and fittings for the Valve Trim
GROOVED SHUT-OFF provide corrosion resistance and are
COUPLING VALVE intended to extend the life of the instal-
lation of the DV-5 Valve when exposed
FIGURE 2 to internal and external corrosive con-
DV-5 PRE-TRIMMED DELUGE VALVE ditions. Although these selections are
ELECTRIC ACTUATION intended to resist corrosion, it is rec-
ommended that the end user or oth-
Technical The trim arrangement is provided with
galvanized, black, or brass nipples and
er technical expert familiar with con-
ditions at the proposed installation be
Data fittings. The galvanized and brass trim
are intended for non-corrosive or cor-
consulted with respect to these selec-
tions for a given corrosive condition.
Approvals rosive conditions, whereas the black Systems using a seawater or brackish
UL and C-UL Listed trim is principally intended for use with water supply require special consid-
FM Approved. AFFF systems. erations in order to extend the life of
NOTE: When the system pressure is the valve and trim. This type of system
Valve Trim greater than 175 psi (12,1 bar), provision ideally should be configured with a pri-
The Vertical Electric Actuation Trim is to be made to replace the standard mary source of clean fresh water (e.g.,
(Fig. 3A/3B) and Horizontal Electric order 300 psi (20,7 bar) Water Pressure a pressurized water tank) and that only
Actuation Trim (Fig. 5) form a part of Gauges, shown in Figure 3A/3B and 5 upon system operation is the second-
the laboratory listings and approvals with separately ordered 600 psi (41,4 ary water supply (seawater or brack-
for the DV-5 Valve and are necessary bar) Water Pressure Gauges. ish water) allowed to enter the system.
for its proper operation. After the system operation, the sys-
The Electric Actuation Trim is required tem should be thoroughly flushed with
Each package of trim includes the fol- for electric operation of the DV-5 Valve
lowing items: clean fresh water. Following this rec-
by a detection system consisting of ommendation will increase the service
• Water Supply Pressure Gauge electrical devices such as heat sen- life of the DV-5 Valve and Valve Trim.
sitive thermostats, smoke detectors,
• Diaphragm Chamber and/or electric manual pull stations. Pressure Gauges. Bronze bourdon
Pressure Gauge Information on the various types of tube with brass socket.
• Diaphragm Chamber Connections separately ordered Solenoid Valves Gauge Test Valve. Bronze body per
that may be used with this trim pack- ASTM B584.
• Manual Control Station age is given in Technical Data Sheet
• Main Drain Valve TFP2180. Nominal installation dimen- Manual Control Station. Corrosion
sions for the Vertical Electric Actuation resistant copper alloys and glass filled
• System Drain Valve PTFE seals. Thermoplastic enclosure.
Trim are shown in Figure 4.
• Alarm Test Valve Automatic Drain Valve. Brass body
NOTE: Approval by Factory Mutu-
• Automatic Drain Valve al is contingent on the use of an FM per ASTM B584, Type 440 stainless
Approved 24VDC Solenoid Valve. FM steel or brass per ASTM B134 Ball, and
The following items are included in the galvanized steel inlet.
Pre-trimmed Valve Assembly and can only approves solenoid valves for use
be ordered separately for the valve in non-hazardous locations. Automatic Shut-Off Valve. Brass
trim: Consult with the authority having ju- body, cover, and center seat per UNS
risdiction regarding installation cri- C36000, Type 316 stainless steel
• Model BFV-N Butterfly Valve spring, and Nylon fabric reinforced,
teria pertaining to electric actuation
• Waterflow Pressure Alarm Switch circuitry. natural rubber diaphragm per ASTM
(PS10-2) D2000.
The Electric Actuation Trim is provided
• Figure 577 Grooved Coupling with a Model ASV-1 Automatic Shut-Off Ball Valve. Corrosion resistant copper
Valve (Item 5 - Fig. 3A and 5); conse- alloys and glass filled PTFE seals.
To ease field assembly of the trim ar-
rangement, the vertical trim compo- quently, the release circuit of the Re- Spring Loaded Check Valve. Brass
nents are provided partially assembled leasing Panel need only provide the body and buna-n seal.
as shown in Figure 3B. standard ten minutes of alarm condi-
 TFP1320
Page 5 of 14

NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N
1 300 psi/ 2000 kPa Water Pressure Gauge . . 2 92-343-1-005 22 3/4" Union. . . . . . . . . . . . . . . . . . . . . . . . . . . 2 CH 43 3/4" x 2" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
2 1/4" Gauge Test Valve . . . . . . . . . . . . . . . . . 1 46-005-1-002 23 1/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 1 CH 44 3/4" x 4" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
3 Model MC-1 Manual Control Station . . . . . . 1 52-289-2-001 24 1/2" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 8 CH 45 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
4 Model AD-1 Automatic Drain Valve . . . . . . . 1 52-793-2-004 25 3/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 1 CH E1 Solenoid Valve Ordered Separately Refer to
5 Model ASV-1 Automatic Shut-Off Valve . . . 1 92-343-1-021 26 1/2" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 CH Per Data Sheet TFP2180 . . . . . . . . . . . . . . . 1 Data Sheet
6 Item No. Not Used 27 1/2" x 1/4" x 1/2" Tee . . . . . . . . . . . . . . . . . . 3 CH E2 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH
7 1/2" Ball Valve . . . . . . . . . . . . . . . . . . . . . . . 2 46-050-1-004 28 3/4" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 CH E3 1/2" x 24" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH
8 1/2" Spring Loaded Check Valve . . . . . . . . . 1 92-322-1-002 29 3/4" x 1/2" x 3/4" Tee . . . . . . . . . . . . . . . . . . 2 CH E4 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
9 1/2" Y-Strainer . . . . . . . . . . . . . . . . . . . . . . . 1 52-353-1-005 30 3/4" x 3/4" x 1/2" Tee . . . . . . . . . . . . . . . . . . 1 CH
10 3/4" Swing Check Valve . . . . . . . . . . . . . . . . 1 46-049-1-005 31 1/4" x Close Nipple. . . . . . . . . . . . . . . . . . . . 2 CH COMPONENTS INCLUDED ONLY IN
11 3/4" Angle Valve . . . . . . . . . . . . . . . . . . . . . . 2 46-048-1-005 32 1/2" x Close Nipple. . . . . . . . . . . . . . . . . . . . 3 CH PRE-TRIMMED VALVE ASSEMBLIES:
12 Drip Funnel Connector . . . . . . . . . . . . . . . . . 1 92-211-1-005 33 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 10 CH A1 Waterflow Pressure Alarm Switch,
13 Drip Funnel Bracket . . . . . . . . . . . . . . . . . . . 1 92-211-1-003 34 1/2" x 2" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH Model PS10-2. . . . . . . . . . . . . . . . . . . . . . . . 1 25710
14 Drip Funnel . . . . . . . . . . . . . . . . . . . . . . . . . . 1 92-343-1-007 35 1/2" x 2-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 4 CH A2 Butterfly Valve, Power Ball 300:
15 3/32" Vent Fitting . . . . . . . . . . . . . . . . . . . . . 1 92-032-1-002 36 1/2" x 5" Nipple. . . . . . . . . . . . . . . . . . . . . . . 2 CH 1-1/2" (DN40) . . . . . . . . . . . . . . . . . . . . . . . . 1 51024A
16 1/4" x 18" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH 37 1/2" x 7" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH 2" (DN50) . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 51021A
17 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH 38 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH A3 Figure 577 Coupling:
18 1/2" x 12" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH 39 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH 1-1/2" (DN40) . . . . . . . . . . . . . . . . . . . . . . . . 1 57715ACP
19 1/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH 40 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH 2" (DN50) . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 57720ACP
20 3/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH 41 3/4" x Close Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
21 1/2" Union. . . . . . . . . . . . . . . . . . . . . . . . . . . 5 CH 42 3/4" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 8 CH
Select Appropriate Nipple Sizes
Nipple per DV-5 Deluge Valve Size
Number
1-1/2" (DN40) 2" (DN50)
16 41 11 38 1/2" x 1-1/2" 1/2" x 2"
A1 39 1/2" x 2" 1/2" x 1-1/2"
30 40 1/2" x 5" 1/2" x 5-1/2"
27 42 45 45 3/4" x 1-1/2" 3/4" x 2-1/2"
15
29 (GREEN E1
LOCATION 24 (ORDERED
20 TINT) 35
FOR OPTIONAL 4 SEPARATELY)
28 E3
ELECTRICALLY 35 42 33
E2 E4
SUPERVISED 42 22 21
N.O. ALARM 43 36 21 32
CONTROL 42 25 33
VALVE 42
22 26
33 10 26
42 42 24 40
24 42 35 24 24
29 12 1
14 26
38 28 33 32
11 44 33 27
7
13 37
35 1 5 33 3
NOTES:
A3
1. Electric Actuation Trim is 21 8
comprised of Items 1-45 19 2 21
plus Items E2-E4. Item E1 A2
36 24 32
ordered separately. Items 34
A1-A3 included only in 39 18
pre-trimmed valve assemblies 9
31 27 33 17
33 24 24
as applicable; otherwise
31 33
ordered separately. 23 2" (DN50)
2. All Fittings and Nipples are GROOVE x GROOVE
galvanized (Standard Order). DV-5 DELUGE VALVE 21
3. CH: Common Hardware. SHOWN
4. See Figure 2 of TFP1305 for 33
Valve Port identification.
5. Route all Tubing to Drip Funnel, 7
Item 14.
FIGURE 3A (1 OF 3)
1-1/2 AND 2 INCH (DN40 AND DN50) DV-5 DELUGE VALVES
EXPLODED VIEW OF VERTICAL ELECTRIC ACTUATION TRIM

Y-Strainer. Bronze body per ASTM Pipe Fittings. Galvanized mallea-

B584 and Type 304 stainless steel ble iron per ANSI B16.3 or cast iron
screen. per ANSI B16.4; black malleable iron
per ANSI B16.3 or cast iron per ANSI
Swing Check Valve. Bronze body per
B16.4; or, bronze per ANSI B16.15.
ASTM B584 and buna-n seal.
Pipe Nipples. Schedule 40 galvanized
Angle Valve. Bronze body per ASTM
steel per ASTM A53 or A135; Sched-
B584 and nitrile disc (TEFLON disc for
ule 40 black steel per ASTM A53 or
2 inch size valve).
A135; or, Schedule 40 red brass pipe
3/32” Vent Fitting. Brass per ASTM per ASTM B43.
B16.
Tubing Connector. Brass per ASTM
B16.
Tubing. Type L copper per ASTM B88.
TFP1320
Page 6 of 14

NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N
1 300 psi/ 2000 kPa Water Pressure Gauge . . 2 92-343-1-005 19 1/2" x 12" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH 37 1/2" x 3-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
2 1/4" Gauge Test Valve . . . . . . . . . . . . . . . . . 1 46-005-1-002 20 1/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH 38 1/2" x 4" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
3 Model MC-1 Manual Control Station . . . . . . 1 52-289-2-001 21 3/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH 39 1/2" x 4-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
4 Model AD-1 Automatic Drain Valve . . . . . . . 1 52-793-2-004 22 1/2" Union. . . . . . . . . . . . . . . . . . . . . . . . . . . 5 CH 40 1/2" x 5" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
5 Model ASV-1 Automatic Shut-Off Valve . . . 1 92-343-1-021 23 3/4" Union. . . . . . . . . . . . . . . . . . . . . . . . . . . 2 CH 41 1/2" x 5-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
6 Item No. Not Used 24 1/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 1 CH 42 1/2" x 7" Nipple. . . . . . . . . . . . . . . . . . . . . . . 2 CH
7 1/2" Ball Valve . . . . . . . . . . . . . . . . . . . . . . . 2 46-050-1-004 25 1/2" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 8 CH 43 3/4" x Close Nipple. . . . . . . . . . . . . . . . . . . . 3 CH
8 1/2" Spring Loaded Check Valve . . . . . . . . . 1 92-322-1-002 26 3/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 1 CH 44 3/4" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 5 CH
9 1/2" Y-Strainer . . . . . . . . . . . . . . . . . . . . . . . 1 52-353-1-005 27 1/2" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 CH 45 3/4" x 2" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
10 3/4" Swing Check Valve . . . . . . . . . . . . . . . . 1 46-049-1-005 28 1/2" x 1/4" x 1/2" Tee . . . . . . . . . . . . . . . . . . 3 CH 46 3/4" x 4-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
11 3/4" Angle Valve . . . . . . . . . . . . . . . . . . . . . . 1 46-048-1-005 29 3/4" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH 47 1-1/4" x 2" Nipple. . . . . . . . . . . . . . . . . . . . . 1 CH
12 1-1/4" Angle Valve . . . . . . . . . . . . . . . . . . . . 1 46-048-1-007 30 3/4" x 1/2" x 3/4" Tee . . . . . . . . . . . . . . . . . . 2 CH 48 1-1/4" x 4" Nipple. . . . . . . . . . . . . . . . . . . . . 1 CH
13 Drip Funnel Connector . . . . . . . . . . . . . . . . . 1 92-211-1-005 31 3/4" x 3/4" x 1/2" Tee . . . . . . . . . . . . . . . . . . 1 CH E1 Solenoid Valve Ordered Separately Refer to
14 Drip Funnel Bracket . . . . . . . . . . . . . . . . . . . 1 92-211-1-003 32 1-1/4" x 3/4" x 1-1/4" Tee. . . . . . . . . . . . . . . 1 CH Per Data Sheet TFP2180 . . . . . . . . . . . . . . . 1 Data Sheet
15 Drip Funnel . . . . . . . . . . . . . . . . . . . . . . . . . . 1 92-343-1-007 33 1/4" x Close Nipple. . . . . . . . . . . . . . . . . . . . 2 CH E2 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH
16 3/32" Vent Fitting . . . . . . . . . . . . . . . . . . . . . 1 92-032-1-002 34 1/2" x Close Nipple. . . . . . . . . . . . . . . . . . . . 2 CH E3 1/2" x 24" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH
17 1/4" x 18" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH 35 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 13 CH E4 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
18 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH 36 1/2" x 2-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 2 CH
COMPONENTS INCLUDED ONLY IN
PRE-TRIMMED VALVE ASSEMBLIES:

17 43 11
A1 Waterflow Pressure Alarm Switch,
Model PS10-2. . . . . . . . . . . . . . . . . . . . . . . . 1 25710
A1 A2 Model BFV-N Butterfly Valve, 3" (DN80) . . . 1 59300F030N
31 A3 Figure 577 Coupling, 3" (DN80) . . . . . . . . . . 1 57730ACP
28 44 46
16 25 E1
30 (GREEN (ORDERED
LOCATION 21 TINT)
36 35 SEPARATELY)
FOR OPTIONAL 26 E3
ELECTRICALLY 36 29 E2 E4
SUPERVISED 44 22
23 27 4 41 22 35
N.O. ALARM 45 35
CONTROL 44 43
VALVE 44 27
23 38
35 10 25 42
43 13
44 25 25
25 15 1
30 27
35 35 34
32 35 28
7 47 48 14
42
12 5 35 3
NOTES: 40
1. Electric Actuation Trim is 1
8
comprised of Items 1-48 22
plus Items E2-E4. Item E1 22
20 2 A3
25 34
ordered separately. Items 37
A1-A3 included only in 19
39 A2 9
pre-trimmed valve assemblies 35 18
35 25 25
as applicable; otherwise 35
33 28 35
ordered separately.
2. All Fittings and Nipples are 33
24
galvanized (Standard Order). 3" (DN80) 22
3. CH: Common Hardware. GROOVE x GROOVE
DV-5 DELUGE VALVE 35
4. See Figure 2 of TFP1305 for
SHOWN
Valve Port identification.
5. Route all Tubing to Drip Funnel, 7
Item 15.
FIGURE 3A (2 OF 3)
3 INCH (DN80) DV-5 DELUGE VALVE
EXPLODED VIEW OF VERTICAL ELECTRIC ACTUATION TRIM
 TFP1320
Page 7 of 14

NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N COMPONENTS INCLUDED ONLY IN
PRE-TRIMMED VALVE ASSEMBLIES:
1 300 psi/ 2000 kPa Water Pressure Gauge . . 2 92-343-1-005 30 1" x 1" x 1/2" Tee . . . . . . . . . . . . . . . . . . . . . 1 CH
2 1/4" Gauge Test Valve . . . . . . . . . . . . . . . . . 1 46-005-1-002 31 1" x 3/4" x 1" Tee . . . . . . . . . . . . . . . . . . . . . 1 CH NO. DESCRIPTION QTY. P/N
3 Model MC-1 Manual Control Station . . . . . . 1 52-289-2-001 32 2" x 1" x 2" Tee . . . . . . . . . . . . . . . . . . . . . . . 1 CH
4 Model AD-1 Automatic Drain Valve . . . . . . . 1 52-793-2-004 33 1/4" x Close Nipple. . . . . . . . . . . . . . . . . . . . 2 CH A1 Waterflow Pressure Alarm Switch,
5 Model ASV-1 Automatic Shut-Off Valve . . . 1 92-343-1-021 34 1/2" x Close Nipple. . . . . . . . . . . . . . . . . . . . 2 CH Model PS10-2. . . . . . . . . . . . . . . . . . . . . . . . 1 25710
6 Item No. Not Used 35 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 10 CH A2 Model BFV-N Butterfly Valve:
7 1/2" Ball Valve . . . . . . . . . . . . . . . . . . . . . . . 2 46-050-1-004 36 1/2" x 2-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 3 CH 4" (DN100). . . . . . . . . . . . . . . . . . . . . . . . . . . 1 59300F040N
8 1/2" Spring Loaded Check Valve . . . . . . . . . 1 92-322-1-002 37 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH 6" (DN150). . . . . . . . . . . . . . . . . . . . . . . . . . . 1 59300F060N
9 1/2" Y-Strainer . . . . . . . . . . . . . . . . . . . . . . . 1 52-353-1-005 38 1/2" x 5" Nipple. . . . . . . . . . . . . . . . . . . . . . . 2 CH 8" (DN200). . . . . . . . . . . . . . . . . . . . . . . . . . . 1 59300F080N
10 3/4" Swing Check Valve . . . . . . . . . . . . . . . . 1 46-049-1-005 39 1/2" x 6" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH A3 Figure 577 Coupling:
11 1" Angle Valve . . . . . . . . . . . . . . . . . . . . . . . 1 46-048-1-006 40 1/2" x 7" Nipple. . . . . . . . . . . . . . . . . . . . . . . 2 CH 4" (DN100). . . . . . . . . . . . . . . . . . . . . . . . . . . 1 57740ACP
12 2" Angle Valve . . . . . . . . . . . . . . . . . . . . . . . 1 46-048-1-009 41 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH 6" (DN150). . . . . . . . . . . . . . . . . . . . . . . . . . . 1 57760ACP
13 Drip Funnel Connector . . . . . . . . . . . . . . . . . 1 92-211-1-005 42 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH 8" (DN200). . . . . . . . . . . . . . . . . . . . . . . . . . . 1 57780ACP
14 Drip Funnel Bracket . . . . . . . . . . . . . . . . . . . 1 92-211-1-003 43 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
15 Drip Funnel . . . . . . . . . . . . . . . . . . . . . . . . . . 1 92-343-1-007 44 3/4" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
16 3/32" Vent Fitting . . . . . . . . . . . . . . . . . . . . . 1 92-032-1-002 45 3/4" x 2" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH Select Appropriate Tube Size
17 Select Tubing per Table . . . . . . . . . . . . . . . . 1 CH 46 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH Tube per DV-5 Deluge Valve Size
18 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH 47 1" x Close Nipple . . . . . . . . . . . . . . . . . . . . . 5 CH No. 4" 6" 8"
19 1/2" x 24" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH 48 1" x 3" Nipple . . . . . . . . . . . . . . . . . . . . . . . . 1 CH (DN100) (DN150) (DN200)
20 1/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH 49 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH 17 1/4" x 24" 1/4" x 24" 1/4" x 32"
21 3/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH 50 2" x 3" Nipple . . . . . . . . . . . . . . . . . . . . . . . . 1 CH
22 1/2" Union. . . . . . . . . . . . . . . . . . . . . . . . . . . 5 CH 51 2" x 5" Nipple . . . . . . . . . . . . . . . . . . . . . . . . 1 CH
23 1" Union . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 CH 52 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH Select Appropriate Nipple Sizes
24 1/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 1 CH E1 Solenoid Valve Ordered Separately Refer to per DV-5 Deluge Valve Size
Nipple
25 1/2" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 8 CH Per Data Sheet TFP2180 . . . . . . . . . . . . . . . 1 Data Sheet
26 1" 90° Elbow. . . . . . . . . . . . . . . . . . . . . . . . . 1 CH No. 4" 6" 8"
E2 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH (DN100) (DN150) (DN200)
27 1/2" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 CH E3 1/2" x 24" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH
28 1/2" x 1/4" x 1/2" Tee . . . . . . . . . . . . . . . . . . 3 CH 37 1/2" x 3" 1/2" x 3" 1/2" x 5"
E4 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
29 3/4" x 1/2" x 3/4" Tee . . . . . . . . . . . . . . . . . . 2 CH 41 1/2" x 2-1/2" 1/2" x 5-1/2" 1/2" x 8-1/2"
42 1/2" x 2" 1/2" x 3" 1/2" x 3-1/2"
43 1/2" x 6-1/2" 1/2" x 7-1/2" 1/2" x 9"
17 47 11 46 3/4" x 2-1/2" 3/4" x 3-1/2" 3/4" x 4-1/2"
A1 30 49 1" x 6" 1" x 9" 1" x 12"
52 1/2" x 7" 1/2" x 7" 1/2" x 9"
47 49
28 E1
29 16 25 (ORDERED
LOCATION 21 (GREEN 36 SEPARATELY)
E3
FOR OPTIONAL TINT) 26 E4
37 E2
ELECTRICALLY 36 47
SUPERVISED 44 4 39 22 42 22
23 23 27 35
N.O. ALARM 45
CONTROL 47
31 36 27
VALVE 25 43
10 47 13
35 25 25
25 46 15 1
48 27
29
35 34
41 35 28
14 52
7 32
50 51 5 35 3
NOTES:
1. Electric Actuation Trim 12
8
is comprised of Items 1-52 1 9 22
40
plus Items E2-E4. Item E1
22 25 34
ordered separately. Items 2 38
20 19
A1-A3 included only in A3
pre-trimmed valve assemblies 38 35 18
as applicable; otherwise 25 25
35 A2 35
ordered separately. 35
33 28
2. All Fittings and Nipples are
galvanized (Standard Order). 33 22
24
3. CH: Common Hardware. 4" (DN100)
4. See Figure 2 of TFP1305 for GROOVE x GROOVE 35
Valve Port identification. DV-5 DELUGE VALVE
SHOWN 7
5. Route all Tubing to Drip Funnel,
Item 15.
FIGURE 3A (3 OF 3)
4, 6, AND 8 INCH (DN100, DN150 AND DN200) DV-5 DELUGE VALVES
EXPLODED VIEW OF VERTICAL ELECTRIC ACTUATION TRIM
TFP1320
Page 8 of 14

Nipple Select Appropriate Nipple and Tube Sizes per DV-5 Deluge Valve Size
Number 1-1/2" (DN40) 2" (DN50) 3" (DN80) 4" (DN100) 6" (DN150) 8" (DN200)
1 1/2" x Close 1/2" x 2" 1/2" x 1-1/2" 1/2" x 2-1/2" 1/2" x 5-1/2" 1/2" x 8-1/2"
2 1/2" x Close 1/2" x Close 1/2" x 1-1/2" 1/2" x 2" 1/2" x 3" 1/2" x 3-1/2"
3 1/2" x 5" 1/2" x 5-1/2" 1/2" x 7" 1/2" x 6-1/2" 1/2" x 7-1/2" 1/2" x 9"
4 3/4" x 1-1/2" 3/4" x 1-1/2" 3/4" x 1-1/2" 3/4" x 2-1/2" 3/4" x 3-1/2" 3/4" x 4-1/2"
5 3/4" x 1-1/2" 3/4" x 2-1/2" 3/4" x 4-1/2" 1" x 6" 1" x 9" 1" x 12"
6 1/2" x 1-1/2" 1/2" x 1-1/2" 1/2" x 1-1/2" 1/2" x 3" 1/2" x 3" 1/2" x 5"
7 1/2" x 7" 1/2" x 7" 1/2" x 7" 1/2" x 7" 1/2" x 7" 1/2" x 9"
Main Drain
3/4" NPT 3/4" NPT 1-1/4" NPT 2" NPT 2" NPT 2" NPT
Size
Tube 1 1/4" x 18" 1/4" x 18" 1/4" x 18" 1/4" x 24" 1/4" x 24" 1/4" x 32"

VENT FITTING NOTES:

(GREEN TINT) 1. Install subassemblies in alphabetical order.
WATERFLOW
PRESSURE ALARM 2. See Figure 2 of TFP1305 for Valve Port
TUBE 1 identification.
SWITCH, ORDERED
SEPARATELY SYSTEM 3. Route all Tubing to Drip Funnel.
DRAIN VALVE 4. When DV-5 trips, Automatic Shut-Off Valve
(NORMALLY shuts off diaphragm chamber supply.
3/4 INCH NPT CLOSED)
CONNECTION FOR 5. Nipples 1-7 and Tube 1 vary in length relative
B
WATER MOTOR to DV-5 size. Select per table. All other nipples
ALARM NIPPLE and tubing packed unassembled shall be
4 installed per appropriate trim exploded view,
AUTOMATIC Figure 3A Part 1, 2, or 3.
LOCATION DRAIN VALVE 1/2 INCH CONDUIT
FOR OPTIONAL
CONNECTION FOR
ELECTRICALLY
NIPPLE "ELECTRIC DETECTION"
SUPERVISED
N.O. ALARM NIPPLE 5
CONTROL 6 SOLENOID VALVE,
VALVE ORDERED SEPARATELY
4" (DN100) (NORMALLY CLOSED)
DRIP
FLANGE x FLANGE
FUNNEL
NIPPLE DV-5 DELUGE NIPPLE
1 VALVE SHOWN 2
1-1/4 INCH NPT
CONNECTION NIPPLE
TO DRAIN 3
MAIN A
DRAIN VALVE DIAPHRAGM
(NORMALLY D CHAMBER
CLOSED) PRESSURE
GAUGE
ALARM MAIN DRAIN NIPPLE
TEST VALVE CONNECTION 7
(NORMALLY (SIZED PER MANUAL
CLOSED) TABLE) CONTROL
STATION
SYSTEM
WATER C AUTOMATIC
SUPPLY DIAPHRAGM
CHAMBER SUPPLY SHUT-OFF VALVE
PRESSURE (NORMALLY
GAUGE CONTROL VALVE
(NORMALLY OPEN)
OPEN) 1/2 INCH NPT
CONNECTION FROM
WATER SUPPLY
FIGURE 3B
1-1/2 THRU 8 INCH (DN40 THRU DN200) DV-5 DELUGE VALVES
OPERATIONAL COMPONENTS OF VERTICAL ELECTRIC ACTUATION TRIM
EXPLODED ARRANGEMENT OF SEMI-PREASSEMBLED TRIM
 TFP1320
Page 9 of 14

Valve Nominal Installation Dimensions in Inches and (mm)

Size A B C D E F G H J K L M N
1-1/2" 7.00 8.88 13.19 10.50 15.25 1.25 5.81 1.81 3.00 7.00 3.88 8.00 4.02
DN40 (177,8) (225,4) (335,0) (266,7) (387,4) (31,8) (147,6) (46,0) (76,2) (177,8) (98,4) (204,0) (102,1)
2" 7.13 9.13 13.19 10.50 15.56 0.94 6.00 2.00 3.00 7.00 3.00 8.63 4.09
DN50 (181,0) (231,8) (335,0) (266,7) (395,3) (23,8) (152,4) (50,8) (76,2) (177,8) (76,2) (220,0) (103,9)
3" 7.81 10.44 13.19 10.50 19.13 1.63 6.69 2.69 4.25 7.00 0.88 12.75 3.85
DN80 (198,4) (265,1) (335,0) (266,7) (485,8) (41,3) (170,0) (68,3) (108,0) (177,8) (22,2) (324,0) (98,0)
4" 10.00 11.75 14.31 10.50 22.13 1.75 8.56 4.44 6.25 7.13 0.63 15.75 4.56
DN100 (254,0) (298,5) (363,5) (266,7) (562,0) (44,5) (217,5) (112,7) (158,8) (181,0) (15,9) (400,0) (116,0)
6" 11.38 14.31 15.31 10.50 23.31 3.50 9.94 5.81 6.25 7.13 1.81 18.13 5.86
DN150 (289,0) (363,5) (388,9) (266,7) (592,1) (88,9) (252,4) (147,6) (158,8) (181,0) (46,0) (460,4) (149,0)
8" 12.00 16.00 16.25 10.50 25.50 1.75 10.75 6.50 6.25 7.13 7.38 22.50 5.26
DN200 (304,8) (406,4) (412,8) (266,7) (647,7) (44,5) (273,1) (165,1) (158,8) (181,0) (187,3) (570,0) (134,0)

* MINIMUM CLEARANCE

A* B C* D*

E*
M
L

N
F
H K

G J

LEFT VIEW FRONT VIEW

FIGURE 4
1-1/2 THRU 8 INCH (DN40 THRU DN200) DV-5 DELUGE VALVES
VERTICAL ELECTRIC ACTUATION / NOMINAL INSTALLATION DIMENSIONS
TFP1320
Page 10 of 14

NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N
1 300 psi/ 2000 kPa Water Pressure Gauge . . 2 92-343-1-005 10 3/4" Swing Check Valve . . . . . . . . . . . . . . . . 1 46-049-1-005 19 1/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH
2 1/4" Gauge Test Valve . . . . . . . . . . . . . . . . . 1 46-005-1-002 11 3/4" Angle Valve . . . . . . . . . . . . . . . . . . . . . . 2 46-048-1-005 20 3/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH
3 Model MC-1 Manual Control Station . . . . . . 1 52-289-2-001 12 Drip Funnel Connector . . . . . . . . . . . . . . . . . 1 92-211-1-005 21 1/2" Union. . . . . . . . . . . . . . . . . . . . . . . . . . . 5 CH
4 Model AD-1 Automatic Drain Valve . . . . . . . 1 52-793-2-004 13 Drip Funnel Bracket . . . . . . . . . . . . . . . . . . . 1 92-211-1-003 22 3/4" Union. . . . . . . . . . . . . . . . . . . . . . . . . . . 2 CH
5 Model ASV-1 Automatic Shut-Off Valve . . . 1 92-343-1-021 14 Drip Funnel . . . . . . . . . . . . . . . . . . . . . . . . . . 1 92-343-1-007 23 1/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 1 CH
6 Item No. Not Used 15 3/32" Vent Fitting . . . . . . . . . . . . . . . . . . . . . 1 92-032-1-002 24 1/2" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 8 CH
7 1/2" Ball Valve . . . . . . . . . . . . . . . . . . . . . . . 2 46-050-1-004 16 1/4" x 18" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH 25 3/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 1 CH
8 1/2" Spring Loaded Check Valve . . . . . . . . . 1 92-322-1-002 17 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH 26 1/2" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 CH
9 1/2" Y-Strainer . . . . . . . . . . . . . . . . . . . . . . . 1 52-353-1-005 18 1/2" x 12" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH 27 1/2" x 1/4" x 1/2" Tee . . . . . . . . . . . . . . . . . . 3 CH
28 3/4" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 CH
E2 29 3/4" x 1/2" x 3/4" Tee . . . . . . . . . . . . . . . . . . 2 CH
30 3/4" x 3/4" x 1/2" Tee . . . . . . . . . . . . . . . . . . 1 CH
33 33 31 1/4" x Close Nipple. . . . . . . . . . . . . . . . . . . . 2 CH
33 24 32 1/2" x Close Nipple. . . . . . . . . . . . . . . . . . . . 3 CH
33 E4 E3
5 40 33 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 10 CH
1 7 24 34 1/2" x 2" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
E1 35 1/2" x 2-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 4 CH
21 9 (ORDERED 36 1/2" x 5" Nipple. . . . . . . . . . . . . . . . . . . . . . . 2 CH
2 8 26 SEPARATELY) 37 1/2" x 7" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
19 38 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
2" (DN50) 24 39 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
GROOVE x GROOVE 32 40 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
33 1 41 3/4" x Close Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
DV-5 DELUGE VALVE 34 42 3/4" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 8 CH
31 31 SHOWN 37 43 3/4" x 2" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
24 33 44 3/4" x 4" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
39 21 45 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
23 21 21
32 26
E1 Solenoid Valve Ordered Separately Refer to
Per Data Sheet TFP2180 . . . . . . . . . . . . . . . 1 Data Sheet
36 33
27 33 27
E2 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH
E3 1/2" x 24" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH
E4 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
21 COMPONENTS ORDERED SEPARATELY:
35 35 3
7 A1 Waterflow Pressure Alarm Switch,
Model PS10-2. . . . . . . . . . . . . . . . . . . . . . . . 1 25710
36
LOCATION 38
FOR OPTIONAL Select Appropriate Nipple Sizes
24 32 Nipple per DV-5 Deluge Valve Size
ELECTRICALLY 33
Number
1-1/2" (DN40) 2" (DN50)
SUPERVISED 38 1/2" x 1-1/2" 1/2" x 2"
N.O. ALARM 29 24 39 1/2" x 2" 1/2" x 1-1/2"
CONTROL 24 17 40 1/2" x 5" 1/2" x 5-1/2"
22 42
VALVE 43 18
45 3/4" x 1-1/2" 3/4" x 2-1/2"
10
42 42 4 NOTES:
20 27 26 1. Electric Actuation Trim is comprised of
29 28 35 Items 1-45 plus Items E2-E4. Items A1
42 14 and E1 ordered separately.
30
35 15 2. All Fittings and Nipples are galvanized
(GREEN
44 (Standard Order).
A1 TINT) 16 12
(ORDERED 3. CH: Common Hardware.
SEPARATELY) 42 4. See Figure 2 of TFP1305 for Valve Port
41 identification.
11 22
5. Route all Tubing to Drip Funnel, Item 14.
42 42 45 13
11 6. Horizontal Arrangement uses only 7 out of
28 25
8 of Item 24, and 9 out of 10 of Item 33.
42 Discard unused material.

FIGURE 5 (1 OF 3)
1-1/2 AND 2 INCH (DN40 AND DN50) DV-5 DELUGE VALVES
EXPLODED VIEW OF HORIZONTAL ELECTRIC ACTUATION TRIM

Installation Heat tracing of the DV-5 Valve or its

associated trim is not permitted. Heat
Step 4. Drain tubing to the Drip Funnel
must be installed with smooth bends
tracing can result in the formation of that will not restrict flow.
General Instructions hardened mineral deposits that are ca-
Proper operation of the DV-5 Deluge Step 5. The main drain and Drip Funnel
pable of preventing proper operation.
Valves depends upon their trim being drain may be interconnected provided
installed in accordance with the in- The DV-5 Deluge Valve is to be in- a check valve is located at least 12
structions given in this Technical Data stalled in accordance with the follow- inches (300 mm) below the Drip Funnel.
Sheet. Failure to follow the appropri- ing criteria: Step 6. Suitable provision must be
ate trim diagram may prevent the DV-5 Step 1. All nipples, fittings, and de- made for disposal of drain water. Drain-
Valve from functioning properly, as well vices must be clean and free of scale age water must be directed such that
as void listings, approvals, and the and burrs before installation. Use pipe it will not cause accidental damage to
manufacturer’s warranties. thread sealant sparingly on male pipe property or danger to persons.
The DV-5 Valve must be installed in a threads only. Step 7. Connect the Diaphragm Cham-
readily visible and accessible location. Step 2. The DV-5 Valve must be ber Supply Control Valve to the inlet
The DV-5 Valve, associated trim, and trimmed in accordance with Figure side of the system’s Main Control Valve
wet pilot lines must be maintained at 3A/3B or 5. in order to facilitate setting of the DV-5
a minimum temperature of 40°F (4°C). Valve (Ref. Figure 4).
Step 3. Care must be taken to ensure
that check valves, strainers, globe Step 8. Unused pressure alarm switch
valves, etc. are installed with the flow connections must be plugged.
arrows in the proper direction.
 TFP1320
Page 11 of 14

NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N
1 300 psi/ 2000 kPa Water Pressure Gauge . . 2 92-343-1-005 6 Item No. Not Used 11 3/4" Angle Valve . . . . . . . . . . . . . . . . . . . . . . 1 46-048-1-005
2 1/4" Gauge Test Valve . . . . . . . . . . . . . . . . . 1 46-005-1-002 7 1/2" Ball Valve . . . . . . . . . . . . . . . . . . . . . . . 2 46-050-1-004 12 1-1/4" Angle Valve . . . . . . . . . . . . . . . . . . . . 1 46-048-1-007
3 Model MC-1 Manual Control Station . . . . . . 1 52-289-2-001 8 1/2" Spring Loaded Check Valve . . . . . . . . . 1 92-322-1-002 13 Drip Funnel Connector . . . . . . . . . . . . . . . . . 1 92-211-1-005
4 Model AD-1 Automatic Drain Valve . . . . . . . 1 52-793-2-004 9 1/2" Y-Strainer . . . . . . . . . . . . . . . . . . . . . . . 1 52-353-1-005 14 Drip Funnel Bracket . . . . . . . . . . . . . . . . . . . 1 92-211-1-003
5 Model ASV-1 Automatic Shut-Off Valve . . . 1 92-343-1-021 10 3/4" Swing Check Valve . . . . . . . . . . . . . . . . 1 46-049-1-005 15 Drip Funnel . . . . . . . . . . . . . . . . . . . . . . . . . . 1 92-343-1-007
16 3/32" Vent Fitting . . . . . . . . . . . . . . . . . . . . . 1 92-032-1-002
17 1/4" x 18" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH
18 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH
E2 19 1/2" x 12" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH
35 35 25 20 1/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH
21 3/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH
35 E4 E3 22 1/2" Union. . . . . . . . . . . . . . . . . . . . . . . . . . . 5 CH
25 23 3/4" Union. . . . . . . . . . . . . . . . . . . . . . . . . . . 2 CH
E1 24 1/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 1 CH
22 9 25 1/2" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 8 CH
34 (ORDERED 26 3/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 1 CH
35 8
42 SEPARATELY) 27 1/2" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 CH
1 5 28 1/2" x 1/4" x 1/2" Tee . . . . . . . . . . . . . . . . . . 3 CH
7 25 35 29 3/4" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH
20 37 1 30 3/4" x 1/2" x 3/4" Tee . . . . . . . . . . . . . . . . . . 2 CH
3" (DN80) 31 3/4" x 3/4" x 1/2" Tee . . . . . . . . . . . . . . . . . . 1 CH
2 25 27 32 1-1/4" x 3/4" x 1-1/4" Tee. . . . . . . . . . . . . . . 1 CH
GROOVE x GROOVE
35 22 33 1/4" x Close Nipple. . . . . . . . . . . . . . . . . . . . 2 CH
DV-5 DELUGE VALVE 42 34 1/2" x Close Nipple. . . . . . . . . . . . . . . . . . . . 2 CH
33 SHOWN 22 35 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 13 CH
33 35 27 36 1/2" x 2-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 2 CH
35 37 1/2" x 3-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
35 28 38 1/2" x 4" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
24 22 39 1/2" x 4-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
35
39 40 1/2" x 5" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
28 41 1/2" x 5-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
3 42 1/2" x 7" Nipple. . . . . . . . . . . . . . . . . . . . . . . 2 CH
22 43 3/4" x Close Nipple. . . . . . . . . . . . . . . . . . . . 3 CH
38 44 3/4" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 5 CH
40 45 3/4" x 2" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
7 41 46 3/4" x 4-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
34 47 1-1/4" x 2" Nipple. . . . . . . . . . . . . . . . . . . . . 1 CH
48 1-1/4" x 4" Nipple. . . . . . . . . . . . . . . . . . . . . 1 CH
LOCATION 35 25 E1 Solenoid Valve Ordered Separately Refer to
FOR OPTIONAL 25 Per Data Sheet TFP2180 . . . . . . . . . . . . . . . 1 Data Sheet
ELECTRICALLY 35
E2 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH
SUPERVISED 18 E3 1/2" x 24" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH
E4 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
N.O. ALARM 30 19
25 COMPONENTS ORDERED SEPARATELY:
CONTROL 23
45 44 A1 Waterflow Pressure Alarm Switch,
VALVE Model PS10-2. . . . . . . . . . . . . . . . . . . . . . . . 1 25710
10
44 44 4
21 28 27 NOTES:
30 36 1. Electric Actuation Trim is comprised of
29
44 15 Items 1-48 plus Items E2-E4. Items A1
31 and E1 ordered separately.
36 16
(GREEN 2. All Fittings and Nipples are galvanized
A1 48 TINT) 17 13 (Standard Order).
(ORDERED
44 3. CH: Common Hardware.
SEPARATELY)
43 4. See Figure 2 of TFP1305 for Valve Port
23 identification.
12
47 43 46 14 5. Route all Tubing to Drip Funnel, Item 15.
32 26 11 6. Horizontal Arrangement uses only 7 out of
43 8 of Item 25, and 12 out of 13 of Item 35.
Discard unused material.
FIGURE 5 (2 OF 3)
3 INCH (DN80) DV-5 DELUGE VALVE
EXPLODED VIEW OF HORIZONTAL ELECTRIC ACTUATION TRIM
Step 9. Conduit and electrical connec-
tions are to be made in accordance
with the requirements of the authority
having jurisdiction and/or the National
Electric Code.
Step 10. Before a system hydrostatic
test is performed in accordance with
NFPA 13 system acceptance test re-
quirements, the DV-5 Diaphragm
Chamber is to be depressurized, the
Automatic Drain Valve (Item 4, Fig. 3A
and 5) is to be temporarily replaced
with a 1/2 inch NPT plug, the 3/32 inch
Vent Fitting (Item 16 - Fig. 3A and 5)
is to be temporarily replaced with a
1/4 inch NPT plug, and the Diaphragm
Cover Bolts must be uniformly and se-
curely tightened using a cross-draw
sequence. After tightening, double-
check to make certain that all of the
Diaphragm Cover Bolts are securely
tightened.
TFP1320
Page 12 of 14

NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N
1 300 psi/ 2000 kPa Water Pressure Gauge . . 2 92-343-1-005 15 Drip Funnel . . . . . . . . . . . . . . . . . . . . . . . . . . 1 92-343-1-007 29 3/4" x 1/2" x 3/4" Tee . . . . . . . . . . . . . . . . . . 2 CH
2 1/4" Gauge Test Valve . . . . . . . . . . . . . . . . . 1 46-005-1-002 16 3/32" Vent Fitting . . . . . . . . . . . . . . . . . . . . . 1 92-032-1-002 30 1" x 1" x 1/2" Tee . . . . . . . . . . . . . . . . . . . . . 1 CH
3 Model MC-1 Manual Control Station . . . . . . 1 52-289-2-001 17 Select Tubing per Table . . . . . . . . . . . . . . . . 1 CH 31 1" x 3/4" x 1" Tee . . . . . . . . . . . . . . . . . . . . . 1 CH
4 Model AD-1 Automatic Drain Valve . . . . . . . 1 52-793-2-004 18 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH 32 2" x 1" x 2" Tee . . . . . . . . . . . . . . . . . . . . . . . 1 CH
5 Model ASV-1 Automatic Shut-Off Valve . . . 1 92-343-1-021 19 1/2" x 24" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH 33 1/4" x Close Nipple. . . . . . . . . . . . . . . . . . . . 2 CH
6 Item No. Not Used 20 1/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH 34 1/2" x Close Nipple. . . . . . . . . . . . . . . . . . . . 2 CH
7 1/2" Ball Valve . . . . . . . . . . . . . . . . . . . . . . . 2 46-050-1-004 21 3/4" Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 CH 35 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 10 CH
8 1/2" Spring Loaded Check Valve . . . . . . . . . 1 92-322-1-002 22 1/2" Union. . . . . . . . . . . . . . . . . . . . . . . . . . . 5 CH 36 1/2" x 2-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 3 CH
9 1/2" Y-Strainer . . . . . . . . . . . . . . . . . . . . . . . 1 52-353-1-005 23 1" Union . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 CH 37 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
10 3/4" Swing Check Valve . . . . . . . . . . . . . . . . 1 46-049-1-005 24 1/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 1 CH 38 1/2" x 5" Nipple. . . . . . . . . . . . . . . . . . . . . . . 2 CH
11 1" Angle Valve . . . . . . . . . . . . . . . . . . . . . . . 1 46-048-1-006 25 1/2" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . . 8 CH 39 1/2" x 6" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
12 2" Angle Valve . . . . . . . . . . . . . . . . . . . . . . . 1 46-048-1-009 26 1" 90° Elbow. . . . . . . . . . . . . . . . . . . . . . . . . 1 CH 40 1/2" x 7" Nipple. . . . . . . . . . . . . . . . . . . . . . . 2 CH
13 Drip Funnel Connector . . . . . . . . . . . . . . . . . 1 92-211-1-005 27 1/2" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 CH 41 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
14 Drip Funnel Bracket . . . . . . . . . . . . . . . . . . . 1 92-211-1-003 28 1/2" x 1/4" x 1/2" Tee . . . . . . . . . . . . . . . . . . 3 CH 42 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
43 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
44 3/4" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
E2 45 3/4" x 2" Nipple. . . . . . . . . . . . . . . . . . . . . . . 1 CH
35 35 25
46 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
47 1" x Close Nipple . . . . . . . . . . . . . . . . . . . . . 5 CH
35 E4 E3 48 1" x 3" Nipple . . . . . . . . . . . . . . . . . . . . . . . . 1 CH
49 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
25
E1 50 2" x 3" Nipple . . . . . . . . . . . . . . . . . . . . . . . . 1 CH
22 9 51 2" x 5" Nipple . . . . . . . . . . . . . . . . . . . . . . . . 1 CH
34 (ORDERED 52 Select Nipple per Table . . . . . . . . . . . . . . . . 1 CH
35 8 SEPARATELY)
43 E1 Solenoid Valve Ordered Separately Refer to
5 Per Data Sheet TFP2180 . . . . . . . . . . . . . . . 1 Data Sheet
7 25 35 E2 1/2" Tubing Connector . . . . . . . . . . . . . . . . . 1 CH
1 1 E3 1/2" x 24" Tubing . . . . . . . . . . . . . . . . . . . . . 1 CH
38 E4 1/2" x 1-1/2" Nipple. . . . . . . . . . . . . . . . . . . . 1 CH
20 4" (DN100) 27
25 35 COMPONENTS ORDERED SEPARATELY:
2 22
GROOVE x GROOVE 52 A1 Waterflow Pressure Alarm Switch,
DV-5 DELUGE VALVE 22
Model PS10-2. . . . . . . . . . . . . . . . . . . . . . . . 1 25710
33 SHOWN 35 27
33
35 35 28 Select Appropriate Tube Size
24 22 42 Tube per DV-5 Deluge Valve Size
No. 4" 6" 8"
38 3 (DN100) (DN150) (DN200)
28 22 17 1/4" x 24" 1/4" x 24" 1/4" x 32"
39
40
7 Select Appropriate Nipple Sizes
34 Nipple per DV-5 Deluge Valve Size
No. 4" 6" 8"
LOCATION 36 (DN100) (DN150) (DN200)
FOR OPTIONAL 41 25 37 1/2" x 3" 1/2" x 3" 1/2" x 5"
25 41 1/2" x 2-1/2" 1/2" x 5-1/2" 1/2" x 8-1/2"
ELECTRICALLY 35 18 42 1/2" x 2" 1/2" x 3" 1/2" x 3-1/2"
SUPERVISED
29 19 43 1/2" x 6-1/2" 1/2" x 7-1/2" 1/2" x 9"
N.O. ALARM 46 3/4" x 2-1/2" 3/4" x 3-1/2" 3/4" x 4-1/2"
CONTROL 25 49 1" x 6" 1" x 9" 1" x 12"
46 23 48
VALVE 45 52 1/2" x 7" 1/2" x 7" 1/2" x 9"
10
44 47 4 NOTES:
21 28 27 1. Electric Actuation Trim is comprised of
29 31 37 Items 1-52 plus Items E2-E4. Items A1
51 30 15 and E1 ordered separately.
36 16
(GREEN 2. All Fittings and Nipples are galvanized
50 (Standard Order).
A1 TINT) 17 13
(ORDERED 3. CH: Common Hardware.
SEPARATELY) 47
12 4. See Figure 2 of TFP1305 for Valve Port
47 identification.
23
47 49 5. Route all Tubing to Drip Funnel, Item 15.
11 14
32 26 6. Horizontal Arrangement uses only 7 out of
8 of Item 25, and 2 out of 3 of Item 36.
47
Discard unused material.

FIGURE 5 (3 OF 3)
4, 6, AND 8 INCH (DN100, DN150, AND DN200) DV-5 DELUGE VALVES
EXPLODED VIEW OF HORIZONTAL ELECTRIC ACTUATION TRIM
 TFP1320
Page 13 of 14

Valve Setting Step 10. Verify the ability for the DV-5
Diaphragm to hold pressure as follows:
The owner is responsible for the in-
spection, testing, and maintenance of
Procedure With the diaphragm chamber pressur-
ized per Step 8, temporarily close the
their fire protection system and devices
in compliance with this document, as
Steps 1 through 11 are to be performed well as with the applicable standards
Diaphragm Chamber Supply Control
when initially setting the DV-5 Deluge of the National Fire Protection Associa-
Valve, and then monitor the Diaphragm
Valve; after an operational test of the tion (e.g., NFPA 25), in addition to the
Chamber Pressure Gauge for a drop in
fire protection system; or, after system standards of any authority having juris-
pressure.
operation due to a fire. diction. Contact the installing contrac-
If a drop in pressure is noted, the DV-5 tor or product manufacturer with any
NOTE: When the system is using ei- Diaphragm is to be replaced and/or any questions.
ther a seawater or brackish water sup- leaks must be corrected before pro-
ply, it is recommended that the system It is recommended that automatic
ceeding to the next step.
be thoroughly flushed with clean fresh sprinkler systems be inspected, tested,
water. Following this recommendation If the Diaphragm Chamber Pressure and maintained by a qualified Inspec-
will increase the service life of the DV-5 Gauge indicates no drop in pressure, tion Service in accordance with local
Valve and Trim. re-open the Diaphragm Chamber Sup- requirements and/or national codes.
ply Control Valve and proceed to the
Step 1. Close the Main Control Valve. next step. NOTICE
Step 2. Close the Diaphragm Chamber Step 11. Slowly open the Main Con- Some of the procedures outlined in
Supply Control Valve. trol Valve. Close the Main Drain Valve this section will result in operation of
Step 3. Open the Main Drain Valve, as soon as water discharges from the the associated alarms. Consequently,
System Drain Valve, and all auxiliary drain connection. Observe the Auto- notification must first be given to the
drains in the system. Close the System matic Drain Valve for leaks. If there are owner and the fire department, central
Drain Valve and auxiliary drain valves leaks, determine/correct the cause of station, or other signal station to which
after water ceases to discharge. Leave the leakage problem. If there are no the alarms are connected.
the Main Drain Valve open. leaks, the DV-5 Valve is ready to be
placed in service and the Main Control When the system is using either a sea-
Step 4. Depress the plunger of the Au- Valve must then be fully opened. water or brackish water supply, inter-
tomatic Drain Valve to verify that it is nal and external inspection of the DV-5
open and that the DV-5 Valve is com- NOTE: When the Main Control Valve Valve and Trim is essential. Parts show-
pletely drained. is opened, the pressure on the Dia- ing any signs of corrosion must be re-
phragm Chamber may increase. This placed to ensure the integrity of the
Step 5. Clean the Strainer in the Dia- increase in pressure is normal, and if system.
phragm Chamber Supply connection the pressure is greater than 250 psi
by removing the clean-out plug and (17,2 bar), the pressure is to be relieved Annual Operation Test Procedure
strainer basket. The Strainer may be by partially and temporarily opening Proper operation of the DV-5 Valve (i.e.,
flushed out by momentarily opening the Manual Control Station; however, opening of the DV-5 Valve as during a
the Diaphragm Chamber Supply Con- do not allow the pressure as indicated fire condition) must be verified at least
trol Valve. on the Diaphragm Chamber Pressure once a year as follows:
Step 6. Reset the actuation system. Gauge to drop below the supply pres- Step 1. If water must be prevented
sure shown on the Water Supply Pres- from flowing beyond the riser, perform
Manual Actuation — Push the operat- sure Gauge, since this action may re-
ing lever up; however, do not close the the following steps:
sult in tripping of the DV-5 Valve.
hinged cover at this time. • Close the Main Control Valve.
After setting a fire protection system,
Electric Actuation — Reset the electric notify the proper authorities and advise • Open the Main Drain Valve.
detection system in accordance with those responsible for monitoring pro- • Open the Main Control Valve one turn
the manufacturer’s instructions to de- prietary and/or central station alarms. beyond the position at which water
energize the solenoid valve. just begins to flow from the Main
Drain Valve.
Step 7. Open the Diaphragm Chamber
Supply Control Valve and allow time Care and • Close the Main Drain Valve.
for full pressure to build up in the Dia-
phragm Chamber. Maintenance Step 2. Test the Deluge Valve Releas-
ing Panel in accordance with the man-
Step 8. Operate (open) the Manu- The following procedures and inspec- ufacturer’s instructions to energize the
al Control Station to vent trapped air tions must be performed as indicated, solenoid valve.
from the Diaphragm Chamber. If nec- in addition to any specific requirements
of the NFPA, and any impairment must NOTE: Be prepared to quickly perform
essary, first open the hinged cover, and Steps 3, 4, and 5, if water must be pre-
then fully pull down on the operating be immediately corrected.
vented from flowing beyond the riser.
lever. Slowly close the operating lever, Before closing a fire protection system
by pushing it up, after aerated water Main Control Valve for maintenance Step 3. Verify that the DV-5 Valve has
ceases to discharge from the Manual work on the fire protection system that tripped, as indicated by the flow of wa-
Control Station drain tubing. Close the it controls, permission to shut down the ter into the system.
hinged cover and insert a new break affected fire protection systems must Step 4. Close the system’s Main Con-
rod in the small hole through the top of first be obtained from the proper au- trol Valve.
the enclosing box. thorities and all personnel who may be
Step 5. Close the Diaphragm Chamber
Step 9. Inspect the drain connections affected by this action must be notified.
Supply Control Valve.
from the Manual Control Station and Reset the DV-5 Deluge Valve in accor-
Solenoid Valve. Any leaks must be cor- dance with the Valve Setting Procedure Step 6. Reset the DV-5 Deluge Valve
rected before proceeding to the next section. in accordance with the Valve Setting
step. Procedure.
TFP1320
Page 14 of 14

Quarterly Waterflow Alarm Test Pre-trimmed DV-5 Assembly

Procedure Electric Actuation Trim
Testing of the system waterflow alarms with Butterfly Valve
must be performed quarterly. To test Specify: (size), G x G End Connection,
the waterflow alarm, open the Alarm Pre-trimmed DV-5 Assembly with But-
Test Valve, which will allow a flow of terfly Valve, P/N (specify):
water to the Pressure Alarm Switch 1-1/2 Inch G x G . . . . . . . . . . . P/N 52-913-0-1AP
and/or Water Motor Alarm. Upon sat- 2 Inch G x G . . . . . . . . . . . . . P/N 52-923-0-1AP
isfactory completion of the test, close 3 Inch G X G . . . . . . . . . . . . . P/N 52-933-0-1AP
the Alarm Test Valve. 4 Inch G x G . . . . . . . . . . . . . P/N 52-943-0-1AP
6 Inch G x G . . . . . . . . . . . . . P/N 52-963-0-1AP
8 Inch G x G . . . . . . . . . . . . . P/N 52-983-0-1AP
Limited Pre-trimmed DV-5 Assembly

Warranty Electric Actuation Trim

without Butterfly Valve
Specify: (specify size), (specify) End
For warranty terms and conditions, visit
Connection, Pre-trimmed DV-5 As-
www.tyco-fire.com.
sembly without Butterfly Valve, P/N
(specify):
Ordering 1-1/2 Inch T x T . . . . . . . . . . . . P/N 52-913-3-1AP
2 Inch T x T . . . . . . . . . . . . . . P/N 52-923-3-1AP
Procedure 3 Inch F x F . . . . . . . . . . . . . . . P/N 52-933-1-1AP
3 Inch F x G . . . . . . . . . . . . . . . P/N 52-933-2-1AP
NOTE: Part Numbers for factory pre- 4 Inch F x F . . . . . . . . . . . . . . . P/N 52-943-1-1AP
4 Inch F x G . . . . . . . . . . . . . . . P/N 52-943-2-1AP
trimmed DV-5 Valves are provided in 6 Inch F x F . . . . . . . . . . . . . . . P/N 52-963-1-1AP
the Price Book. 6 Inch F x G . . . . . . . . . . . . . . . P/N 52-963-2-1AP
8 Inch F x F . . . . . . . . . . . . . . . P/N 52-983-1-1AP
DV-5 Semi-Preassembled Vertical 8 Inch F x G . . . . . . . . . . . . . . . P/N 52-983-2-1AP
Electric Actuation Trim Accessories
Specify: (specify size and finish — gal- Refer to the Technical Data Sheets for
vanized is standard) Semi-Preassem- the following, as applicable, for details
bled Vertical Electric Actuation Trim for and additional accessories:
DV-5 Deluge Valves, P/N (specify):
600 PSI Water
1-1/2 & 2 Inch Galvanized . . . . P/N 52-477-2-309 Pressure Gauge . . . . . . . . . . . P/N 92-343-1-004
1-1/2 & 2 Inch Black . . . . . . . . P/N 52-477-1-309 Solenoid Valve for
1-1/2 & 2 Inch Brass . . . . . . . . P/N 52-477-3-309 Electric Actuation . . . . . . . . . . . . . . See TFP2180
Model PS10-2
3 Inch Galvanized . . . . . . . . . . P/N 52-477-2-106 Potter Electric
3 Inch Black . . . . . . . . . . . . . . P/N 52-477-1-106 Waterflow
3 Inch Brass . . . . . . . . . . . . . . P/N 52-477-3-106 Pressure
Alarm Switch . . . . . . . . . . . . . . . . . . . . P/N 25710
Model WMA-1 Water
4, 6 & 8 Inch Galvanized . . . . . P/N 52-477-2-303 Motor Alarm . . . . . . . . . . . . . . P/N 52-630-1-001
4, 6 & 8 Inch Black . . . . . . . . . P/N 52-477-1-303 Replacement Trim Parts
4, 6 & 8 Inch Brass . . . . . . . . . P/N 52-477-3-303
Specify: (description) for use with DV-5
DV-5 Unassembled Electric Deluge Valve, P/N (see Figure 3A or 5).
Actuation Trim for Vertical or Accessories
Horizontal Installation Refer to the Technical Data Sheets for
Specify: (specify size and finish — gal- the following, as applicable, for details
vanized is standard) Unassembled and additional accessories:
Electric Actuation Trim for Vertical or
Horizontal Installation of DV-5 Deluge 600 PSI Water
Pressure Gauge . . . . . . . . . . . P/N 92-343-1-004
Valves, P/N (specify): Model PS10-2
1-1/2 & 2 Inch Galvanized . . . . P/N 52-477-2-209 Potter Electric
1-1/2 & 2 Inch Black . . . . . . . . P/N 52-477-1-209 Waterflow
1-1/2 & 2 Inch Brass . . . . . . . . P/N 52-477-3-209 Pressure
Alarm Switch . . . . . . . . . . . . . . . . . . . . P/N 25710
Model WMA-1 Water
3 Inch Galvanized . . . . . . . . . . P/N 52-477-2-206 Motor Alarm . . . . . . . . . . . . . P/N 52-630-1-001P
3 Inch Black . . . . . . . . . . . . . . P/N 52-477-1-206 Model MC-1
3 Inch Brass . . . . . . . . . . . . . . P/N 52-477-3-206 Manual Control
Stations with
Galvanized
4, 6 & 8 Inch Galvanized . . . . . P/N 52-477-2-203 Connections for
4, 6 & 8 Inch Black . . . . . . . . . P/N 52-477-1-203 Remote Wet Pilot
4, 6 & 8 Inch Brass . . . . . . . . . P/N 52-477-3-203 Actuation . . . . . . . . . . . . . . . . . P/N 52-289-2-001
Replacement Trim Parts
Specify: (description) for use with DV-5
Deluge Valve, P/N (see Figure 3A or 5)

GLOBAL HEADQUARTERS | 1400 Pennbrook Parkway, Lansdale, PA 19446 | Telephone +1-215-362-0700

Copyright © 2014 Tyco Fire Products, LP. All rights reserved.
TEFLON is trademark of The DuPont Corporation.