Scribd
Upload
5K views1 page

Isuzu T4i Engine Error Codes

The document lists error codes, failure modes, and messages displayed for an Isuzu Tier 4i engine. It includes over 50 diagnostic trouble codes (DTCs) ranging from issues with the crankshaft position, turbocharger, fuel system, sensors, exhaust system, engine electronics, and more. For each code it indicates whether the caution light, buzzer, or message displayed advise of no restart, low power, or high water temperature.

Uploaded by

morus
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
5K views1 page

Isuzu T4i Engine Error Codes

The document lists error codes, failure modes, and messages displayed for an Isuzu Tier 4i engine. It includes over 50 diagnostic trouble codes (DTCs) ranging from issues with the crankshaft position, turbocharger, fuel system, sensors, exhaust system, engine electronics, and more. For each code it indicates whether the caution light, buzzer, or message displayed advise of no restart, low power, or high water temperature.

Uploaded by

morus
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
You are on page 1/ 1

ENGINE FAULT LED

Isuzu Tier 4i Engine error codes

ERROR CODE DISPLAYED

MESSAGE DISPLAYED
CAUTION LED

BUZZER ON (1.5S)
DTC
CODE FAILURE MODE / TYPE
P0016 Crankshaft position Correlation     NO RESTART
P0045 Turbocharger boost solenoid    NO RESTART
P0087 Fuel rail pressure too low    LOW POWER
P0088 Fuel rail pressure too high    LOW POWER
P0089 Fuel pressure reg performance    LOW POWER
P0091 Fuel pressure reg control circuit low    LOW POWER
P0092 Fuel pressure reg control circuit high    LOW POWER
P0093 Fuel system leak detected    LOW POWER
P0102 MAF Low Voltage Fault    LOW POWER
P0103 MAF High Voltage Fault    LOW POWER
P0107 Boost Pressure Sensor Fault （Low Voltage Fault）    LOW POWER
P0108 Boost Pressure Sensor Fault （High Voltage Fault）    LOW POWER
P0112 Inlet Air Temperature Sensor Fault （Low Voltage Fault）    LOW POWER
P0113 Inlet Air Temperature Sensor Fault （High Voltage Fault）    LOW POWER
P0117 Coolant Temperature Sensor Fault （Low Voltage Fault）    LOW POWER
P0118 Coolant Temperature Sensor Fault （High Voltage Fault）    LOW POWER
P0122 Intake Throttle Position Low Voltage Fault    LOW POWER
P0123 Intake Throttle Position High Voltage Fault    LOW POWER
P0181 Fuel Temperature Sensor Fault    LOW POWER
P0182 Fuel Temperature Sensor Fault （Low Voltage Fault）   
P0183 Fuel Temperature Sensor Fault （High Voltage Fault）   
P0192 Common Rail Pressure Sensor Fault (Low Voltage Fault)    LOW POWER
P0193 Common Rail Pressure Sensor Fault (High Voltage Fault)    LOW POWER
P0201 Injection Nozzle #1Drive System Open Circuit Fault    LOW POWER
P0202 Injection Nozzle #2Drive System Open Circuit Fault    LOW POWER
P0203 Injection Nozzle #3Drive System Open Circuit Fault    LOW POWER
P0204 Injection Nozzle #4Drive System Open Circuit Fault    LOW POWER
P0205 Injection Nozzle #5Drive System Open Circuit Fault    LOW POWER
P0206 Injection Nozzle #6Drive System Open Circuit Fault    LOW POWER
P0217 Overheat  WATER TEMP
P0219 Engine overspeed  
P0234 Turbo Over Boost    LOW POWER
P0299 Turbo Low Boost    LOW POWER
P0335 Crank Sensor Fault （No Signal）    LOW POWER
P0340 Cam sensor malfunction     NO RESTART
P0404 EGR Open Defective    NO RESTART
P0409 EGR Position Sensor Fault （Brushless Specification）    LOW POWER
P041C Manifold Temperature Sensor Fault （High Voltage Fault）  
P041D Manifold Temperature Sensor Fault （Low Voltage Fault）  
P0426 DPF Exhaust Temperature    LOW POWER
P0427 Exhaust Temperature Sensor 1Low Voltage Fault    LOW POWER
P0428 Exhaust Temperature Sensor 1High Voltage Fault    LOW POWER
P042B DPF Exhaust Temperature 2 Low    LOW POWER
P042C Exhaust Temperature Sensor 2 Low Voltage Fault    LOW POWER
P042D Exhaust Temperature Sensor 2 High Voltage Fault    LOW POWER
P0522 Engine Oil Pressure Sensor Fault (Low Voltage Fault)  
P0523 Engine Oil Pressure Sensor Fault (High Voltage Fault)  
P0560 12V Power Supply Voltage Fault    LOW POWER
P0562 System Power Supply Low Voltage Fault   
P0563 System Power Supply High Voltage Fault   
P0601 ROM Fault    LOW POWER
P0602 QR Code Error    LOW POWER
P0604 RAM Fault    LOW POWER
P0606 CPU Fault    LOW POWER
P0606 CPU Monitoring IC Fault    LOW POWER
P060B A/D Conversion Fault    LOW POWER
P0615 Starter Cut Relay Fault   
P0638 Intake Throttle Fault    LOW POWER
P0641 5V Power Supply-1 Voltage Fault    LOW POWER
P0641 5V Power Supply-6 Voltage Fault    LOW POWER
P0651 5V Power Supply-5 Voltage Fault    LOW POWER
P0685 Main Relay System Fault (Open)  
P0687 Main Relay System Fault (Close)  
P0697 5V Power Supply-3 Voltage Fault    LOW POWER
P1093 Common Rail Pressure Fault (Lack of Feed 1)    LOW POWER
P1093 Common Rail Pressure Fault (Lack of Feed)    LOW POWER
P1112 Boost Temperature Sensor Fault (Low Voltage Fault)  
P1113 Boost Temperature Sensor Fault (High Voltage Fault)  
P1261 Charge Circuit Fault （Bank 1）    LOW POWER
P1262 Charge Circuit Fault （Bank 2）    LOW POWER
P1293 Fuel Filter Clogging Sensor Fault (Low Voltage Fault)   
P1294 Fuel Filter Clogging Sensor Fault (High Voltage Fault)   
P1404 EGR Zero Position Fault    LOW POWER
P1404 EGR Close Defective
P140A EGR 2 Valve Control Fault    LOW POWER
P140B EGR 2 Position Sensor Fault    LOW POWER
P140C EGR 2 Zero Position Fault    LOW POWER
P1455 DPF PM Over 2    LOW POWER
P1471 DPF Regeneration Defective    LOW POWER
P1621 EEPROM Fault
P1655 5V Power Supply-4 Voltage Fault    LOW POWER
P1669 DPF Lamp Fault  
P2146 Injection Nozzle Common 1 Drive System Fault    LOW POWER
P2149 Injection Nozzle Common 2 Drive System Fault    LOW POWER
P2227 Baro Sensor Fault    LOW POWER
P2228 Baro Sensor Fault （Low Voltage Fault）    LOW POWER
P2229 Baro Sensor Fault （High Voltage Fault）    LOW POWER
P242F DPF PM Over    LOW POWER
P2452 DPF Differential Pressure Low    LOW POWER
P2453 DPF Differential Pressure High    LOW POWER
P2454 Differential Pressure Sensor Low Voltage Fault    LOW POWER
P2455 Differential Pressure Sensor High Voltage Fault    LOW POWER
P2456 Differential Pressure Sensor Zero Position Learning Fault    LOW POWER
P2458 DPF Regeneration Timeout Excess Frequency    LOW POWER

27/09/2012

You might also like