Scribd
Upload
61 views5 pages

Body Electrical System

Uploaded by

Carlos Luis Santos Somcar
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
61 views5 pages

Body Electrical System

Uploaded by

Carlos Luis Santos Somcar
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
You are on page 1/ 5

2002 Toyota RAV4

2002 ACCESSORIES & EQUIPMENT Ignition Switch & Key Unlock Warning System - RAV4

2002 ACCESSORIES & EQUIPMENT

Ignition Switch & Key Unlock Warning System - RAV4

BODY ELECTRICAL SYSTEM


PRECAUTION

NOTE: Take care to observe the following precautions when performing inspections or
removal and replacement of body electrical related parts.

1. Headlight System

Halogen bulbs have pressurized gas inside and require special handling. They can burst if scratched or
dropped. Hold a bulb only by its plastic or metal case.

Don't touch the glass part of a bulb with bare hands.

2. SRS (Supplemental Restraint System)

The RAV4 is equipped with an SRS (Supplemental Restraint System) such as the driver airbag and front
passenger airbag, failure to carry out service operation in the correct sequence could cause the SRS to
unexpectedly deploy during servicing, possibly leading to a serious accident. Before servicing (including
removal or installation of parts, inspection or replacement), be sure to read the precautionary notices in
AIR BAG SAFETY PRECAUTIONS .

3. Audio System

If the negative (-) terminal cable is disconnected from the battery, the preset AM, FM1 and FM2 stations
stored in memory are erased, so be sure to note the stations and reset them after the battery terminal is
reconnected.

4. Mobile Communication System

If the vehicle is equipped with a mobile communication system, refer to precautions in IF VEHICLE IS
EQUIPPED WITH MOBILE COMMUNICATION SYSTEM .

TROUBLESHOOTING
PROBLEM SYMPTOMS

IGNITION SWITCH AND KEY UNLOCK WARNING SWITCH


Symptom/Suspected Area See
Ignition Switch Is Not Set To Each Position
Ignition Switch Step 1 under INSPECTION
Helpmelearn
November-03-08 5:27:39
5:27:30 PM Page 1 © 2005 Mitchell Repair Information Company, LLC.
2002 Toyota RAV4
2002 ACCESSORIES & EQUIPMENT Ignition Switch & Key Unlock Warning System - RAV4

Key Unlock Warning System Does Not Operate


GAUGE Fuse FUSES & CIRCUIT BREAKERS
Key Unlock Warning Switch Step 2 under INSPECTION
Door Courtesy Switch INSPECTION
Wire Harness .....

IGNITION SWITCH AND KEY UNLOCK WARNING SWITCH


LOCATION

Fig. 1: Locating Ignition Switch & Key Unlock Warning Switch


Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

Helpmelearn
November-03-08 5:27:30 PM Page 2 © 2005 Mitchell Repair Information Company, LLC.
2002 Toyota RAV4
2002 ACCESSORIES & EQUIPMENT Ignition Switch & Key Unlock Warning System - RAV4

INSPECTION

1. Inspect ignition switch continuity .

Fig. 2: Inspecting Ignition Switch Continuity


Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

Fig. 3: Displaying Switch Specifications


Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
Helpmelearn
November-03-08 5:27:30 PM Page 3 © 2005 Mitchell Repair Information Company, LLC.
2002 Toyota RAV4
2002 ACCESSORIES & EQUIPMENT Ignition Switch & Key Unlock Warning System - RAV4

If continuity is not as specified, replace the switch.

2. Inspect key unlock warning switch continuity .

If continuity is not as specified, replace the switch.

Fig. 4: Inspecting Key Unlock Switch Continuity


Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

Fig. 5: Displaying Key Unlock Switch Specifications


Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

3. Inspect key unlock warning buzzer .


Helpmelearn
November-03-08 5:27:30 PM Page 4 © 2005 Mitchell Repair Information Company, LLC.
2002 Toyota RAV4
2002 ACCESSORIES & EQUIPMENT Ignition Switch & Key Unlock Warning System - RAV4

Fig. 6: Displaying Key Unlock Buzzer Specifications


Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

Check the buzzer sound when driver's door is opened and key inserted.

If operation is not as specified, replace the combination meter (See REMOVAL ).

Helpmelearn
November-03-08 5:27:31 PM Page 5 © 2005 Mitchell Repair Information Company, LLC.

You might also like