Wire Description

Diagnostic Codes For Hydrostatic Transmission

ECM (MID No. 079)(1)
Wire Wire
Description
Wire Wire
Description RENR5807-01
Harness And Wire Electrical Schematic Symbols
Number Color Number Color
For troubleshooting, see the procedure with the Power Circuits Accessory Circuits (Continued) October 2007 Symbols
same CID And FMI No. 101 RD Bat (+) (Not Application Specific) 504 YL Wiper - Rear (Low)
102 BU Hd Lmp 506 PU Washer - Front
CID / FMI Description 103 YL Lighting 2 508 PU Radio Speaker - Left

CID 0041 Sensor Power Supply (8 DCV) 104 YL Starting 509 WH Radio Speaker - Left (Commom) T
Conversion Table for the Diagnostic Codes
FMI 00 Data Valid but above normal operating
105 RD Key Sw 511 BR Radio Speaker - Right Pressure Temperature Level Flow Circuit Breaker
range. Codes Component Description 106 WH Detent 512 GN Radio Speaker - Right (Common) Symbol Symbol Symbol Symbol Symbol
Identifier 108 BU Radio 515 GY Blower Motor (HI)
FMI 01 Data Valid but below normal operating
range. 124 CID 0041 Sensor Power Supply (8 DCV)
109 RD Alt Output (+) Term. 516 GN Blower Motor (Medium) Symbols and Definitions
112 PU Main Power Rly Output 517 BU Blower Motor (Low)
244 CID 0070 Rocker Switch (Parking Brake) Fuse - A component in an electrical circuit that will open the circuit if too much current flows
CID 0070 Rocker Switch (Parking Brake) 114 RD Warning Horn (Forward) 521 YL A/C SW To Refrigerant SW
through it.
115 RD Glow Plug / Auxiliary Breaker 522 WH A/C Clutch To Thermostat SW
FMI 02 Data erratic, intermittent, or incorrect. 245 CID 0133 Solenoid Valve (Transmission Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
117 RD Engine Shutdown Timer 523 BR Wiper - Left (Park)
Pilot Pressure) circle indicates that the component has screw terminals and a wire can be disconnected from it.
CID 0133 Solenoid Valve (Transmission Pilot 119 PK Front / Rear Wiper 524 BU Wiper - Left (Low)
Pressure) 246 CID 0153 Speed Sensor (Right Track) 120 YL Left Door Wiper 525 GY Wiper - Left (HI)
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
FMI 03 Voltage above normal or shorted high. 122 BU Right Door Wiper 526 YL Wiper - Right (Park) No circle indicates that the wire cannot be disconnected from the component.
251 CID 0154 Speed Sensor (Left Track)
123 WH Monitoring 527 GN Wiper - Right (Low)
FMI 05 Current below normal or open circuit. 411 CID 0168 Electrical System 124 GN A/C 528 PK Wiper - Right (HI) Ground (Wired): This indicates that the component is connected to a grounded wire. The
FMI 06 Current above normal or grounded circuit. 125 OR HVAC Breaker to HVAC High Speed Relay 529 WH Washer Left grounded wire is fastened to the machine.
141 CID 0190 Engine Speed Sensor
126 PK Xmsn Ctrl 530 WH Washer Right
CID 0153 Speed Sensor (Right Track) 144 CID 0444 Magnetic Switch (Start Relay) 129 BU Product Link / Power Port 567 WH A/C SW Jumper Ground (Case): This indicates that the component does not have a wire connected to ground.
FMI 08 Abnormal frequency, pulse width, or period. 158 BR HVAC Condenser Relay 1 589 GN A/C HI Press. Cutout SW To Compressor It is grounded by being fastened to the machine.
252 CID 0468 Position Sensor (Service
Brake Pedal) 159 BU HVAC Condenser Relay 2 C546 WH Blower MED-Low Relay
CID 0154 Speed Sensor (Left Track)
177 RD Main Brkr C547 OR Blower Motor (MED-Low)
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
FMI 08 Abnormal frequency, pulse width, or period. 421 CID 0637 Backup Alarm Ground Circuits C556 BU Relay to Condensor Motor 1 contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
CID 0168 Electrical System 426 CID 0650 Harness Code 200 BK Main Chassis C557 OR Relay to Condensor Motor 2

FMI 03 Voltage above normal or shorted high.

253 CID 0681 Solenoid Valve (Parking
Brake)
202
276
BK
BK
XMSN Ctrl
XMSN Ctrl Ident Code 0 607 PK
Lighting Circuits
Flood Lamp - Front D3G, D4G & D5G HYSTAT Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to

Track-Type Tractors
T
FMI 04 Voltage below normal or shorted low. 277 BK XMSN Ctrl Ident Code 1 614 PU Park/Tail/Dash/Lamp the gauge of the temperature or pressure.

CID 0190 Engine Speed Sensor 422 CID 1482 Sensor Power Supply (10 278 BK XMSN Ctrl Ident Code 2 Control Circuits
DCV) 279 BK XMSN Ctrl Ident Code 3 709 OR Sensor Power Supply Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.

Electrical System
FMI 08 Abnormal frequency, pulse width or period. It has a coil that makes an electromagnet when current flows through it. The
Basic Machine Circuits 769 BU Wheel Speed Pickup Left
Position Sensor (Deceleration electromagnet can open or close the switch part of the relay.
254 CID 1693 304 WH Starter Relay No. 1 Output 770 GN Wheel Speed Pickup Right
CID 0444 Magnetic Switch (Start Relay) Pedal)
306 GN Starter Relay Coil To Neut Start SW Or Key SW C703 BR Direction Cont - N SW To Select SW Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
FMI 03 Voltage above normal or shorted high. Position Sensor 308 YL Main Power Relay Coil F750 YL 3.5A Return coil that makes an electromagnet when current flows through it. The electromagnet
255 CID 1699
FMI 05 Current below normal or open circuit. (Forward/Neutral/Reverse) 310 PU Start Aid SW To Start Aid Sol F773 OR Governor Accel D3G: D4G: D5G: can open or close a valve or move a piece of metal that can do work.

FMI 06 Current above normal or grounded circuit. 256 CID 1700 Position Sensor (Joystick) 314 PU Starter Relay No. 2 Output F774 WH Governor Decel
CFC1-UP FDC1-UP FDH1-UP MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is
320 OR Horn Relay Coil To SW G745 PK Brake Pedal Sensor
CID 0468 Position Sensor (Service Brake Pedal) 261 CID 1701 Position Sensor (Left Pedal) 321 BR Backup Alarm Lamp Travel Alarm J764 BR Switch/Sensor Return #1 CFF1-UP CFN1-UP FDW1-UP activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
262 322 GY Warning Horn (Forward) M730 YL Governer Motor Sensor Signal
FMI 03 Voltage above normal or shorted high. CID 1702 Position Sensor (Left Pedal) the latch coil circuit open at the time the coil latches.
327 PK Shutdown Solenoid 833 GY Hydrst Right Motor Speed Sensor
FMI 04 Voltage below normal or shorted low. Proportional Solenoid Valve
263 CID 1703
(Forward Left Drive Pump)
374 PK Neutral Start SW To Park Brake SW 835 PU Hydrst Left Motor Speed Sensor
Harness and Wire Symbols
FMI 08 Abnormal frequency, pulse width or period. 383 GN Ether Aid Sol #1 (-) 899 BU Hydrst Track Speed Increase

Proportional Solenoid Valve 384 BU Relay To Glow Plugs F853 BR Travel Speed 1 Deutsch connector: Typical representation 1 Sure-Seal connector: Typical representation
FMI 13 Out of calibration. 264 CID 1704 of a Deutsch connector. The plug contains all of a Sure-Seal connector. The plug and receptacle
(Reverse Left Drive Pump) A314 OR Park Brake SW to Trans Neutralizer Relay Set H801 PU Proportional Driver Return (1-4) 2 sockets and the receptacle contains all pins. 2 contain both pins and sockets.
CID 0637 Backup Alarm A315 WH Park Brake SW to Trans Neutralizer Relay Reset H802 GY Proportional Driver Return (5-8)
265 CID 1705 Proportional Solenoid Valve Harness Identification Letter(s):
Monitoring Circuits H803 BU Proportional Driver Return (9-12)
FMI 03 Voltage above normal or shorted high. (Reverse Right Drive Pump) Wire, Cable, or Harness Assembly Identification: (A, B, C, ..., AA, AB, AC, ...)
403 GN Alternator (R) Term. H807 YL On/Off Driver Return (1-8) Includes Harness Identification Letters and Harness
Connector Serialization Codes Harness Connector Serialization Code: The "C" stands
FMI 06 Current above normal or grounded circuit. Proportional Solenoid Valve 410 WH Opr Mon Fault Alarm J847 GN VIMS Action Alarm Return for "Connector" and the number indicates which
271 CID 1706
(Reverse Right Drive Pump) 441 OR Eng Coolant Temp Gage J848 BU VIMS Service Lamp Return Part Number for
connector in the harness. (C1, C2, C3, .....)
CID 0650 Harness Code AG-C4 L-C12
443 YL Power Train Temp Gage 915 GN TEHC Pilot Override Valve
C-C4 AG-C3 Connector Plug Part Number For
Proportional Solenoid Valve 130-6795 130-6795 111-7898 3E-5179 Connector Recepticle
FMI 12 Bad device or component failed. 272 CID 1707 447 PK Fuel Level Gage 944 OR Data Link + (CAT)
(Left Drive Motor) 1
325-AG135 PK-14 5A
CID 0681 Solenoid Valve (Parking Brake) 450 YL Tach Sender (+) 945 BR Data Link - (CAT)
273 CID 1708 Proportional Solenoid Valve 451 BR Tach Sender (-) A958 WH Park Brake Sol
Pin Socket
Receptacle
Fuse
FMI 03 Voltage above normal or shorted high. (Right Drive Pump) Pin or Socket (5 Amps)
464 GY Opr Mon Panel Eng Oil Press. Sensor C920 GY Fault Lamp - Control Single Wire
Number
9X-1123
Connector
FMI 05 Current below normal or open circuit. 497 BU Sensor Power C958 BU Motor Speed Hi/Lo (Right) MTS Paver Component
Part Number
C444 YL Alternator Indicator Lamp (Was B404) C959 BR Motor Speed Hi/Lo (Left) MTS Paver Plug
FMI 06 Current above normal or grounded circuit. Harness identification code: 2 200-L32 BK-14
C446 PK Power Train Filter Warning (Was B446) E953 GY Track Travel Speed SW to Solenoid This example indicates wire
CID 1482 Sensor Power Supply (10 DCV) C491 PU Park Brake Pressure F931 PK AMT Park Brake Sol Ret 135 in harness "AG".
Circuit Identification
Ground Wire Gauge
Connection Number Wire Color
FMI 00 Data Valid but above normal operating F400 GY Low Oil Pressure K943 OR Travel Left Sol Rear
range. Accessory Circuits K946 OR Travel Right Sol Rear
500 BR Wiper - Front (Park) K947 YL Travel Right Sol Front
FMI 01 Data Valid but below normal operating © 2007 Caterpillar Printed in U.S.A.
501 GN Wiper - Front (Low) K994 BU Auto Retard Service Clear (Was D994)
range.
503 BR Wiper - Rear (Park) R981 YL Travel Speed Sol to Travel Speed Sw All Rights Reserved
CID 1693 Position Sensor (Deceleration Pedal)
FMI 03 Voltage above normal or shorted high.
FMI 04 Voltage below normal or shorted low.
FMI 08 Abnormal frequency, pulse width or period.
FMI 13 Out of calibration.
CID 1699 Position Sensor (Forward/Neutral/Reverse) Blower Unit Resistor 139-3900

FMI 03 Voltage above normal or shorted high. 3 5 A B C D

64 18 A-B Tap
Component Location 43 A-C Tap
FMI 04 Voltage below normal or shorted low. 10 10 7 8 2
21 6 A-D Tap
Schematic Machine Schematic Machine 39 42
Component Component 53 41 11
Location Location Location Location 37
FMI 08 Abnormal frequency, pulse width or period. 8
6 Glow Plugs E-2 1 Power Stud C-8 16 46 57 15 13 14 16 34 Connector Location
65 19
FMI 13 Out of calibration. ABL2CS Control (ECM) G-11 42 Radio E - 12 29 25
60 Schematic Machine
A/C ARC Supressor E-1 2 Relay - 1 B - 15 40 26 35 49 11 18 Connector Number
67 Location Location
CID 1700 Position Sensor (Joystick) A/C Comp. Clutch Sol. F-1 56 Relay - 2 A- 15 40 6 51
40 66 5 48 45 1 2 13 CONN 1 B-15 1
Alarm - Backup F - 13 3 Relay - Glow Plug I - 13 41 63 7 56
FMI 03 Voltage above normal or shorted high. 1 47 29 17 52 CONN 2 C-15 1
Alternator C-1 4 Relay - High Speed E-9 66
4 32 9 12 12 CONN 3 D-15 1
FMI 04 Voltage below normal or shorted low. Antenna Lead E - 12 5 Relay - Horn E-9 42 44
58
14 20
Arc Suppressor C-2 6 Relay - Main Power H - 13 41 CONN 4 B-14 2 Resistor, Sender and Solenoid Specifications
FMI 08 Abnormal frequency, pulse width or period. 15 16 Part No. Component Description Resistance (Ohms)¹

(Dimensions: 39 inches x 24 inches)

Backlight - 1 G-7 7 Relay - Motor Start I - 13 42 CONN 5 A-14 3
Backlight - 2 G-7 7 Relay - Starting E-9 43 27 CONN 6 C-13 4 A-B Tap 0.25 ± 0.025
FMI 13 Out of calibration. 55 4
Battery D - 11 8 Resistor - Blower Unit D - 10 44 CONN 7 F-13 5 139-3900 Resistor - Blower Unit Resistor (See Illustration above) A-C Tap 0.5 ± 0.05
CID 1701 Position Sensor (Left Pedal) Battery - 1 HD E - 11 8 Sender - Coolant Temp G-2 4
23 36 54 50 CONN 8 F-13 6 A-D Tap 1.0 ± 0.1
Battery - 2 HD E - 11 8 Sender - Engine Oil Pressure E-2 45 69 183-4584 Sensor - Left and Right Track Speed 2000 ± 20
FMI 02 Data erratic, intermittent, or incorrect. 24
CONN 9 G-13 6
Blower E - 10 9 Sender - Fuel Level G - 13 46 68 61 30
38

RENR5807-01
Breaker - Alternator F - 11 10 Sensor - CTR Brake Pedal B-7 47 CONN 10 E-12 7 560 - 716 @ 54.40 ºC (129.9ºF)
CID 1702 Position Sensor (Left Pedal) 62 17 22 7W-9943 Sender - Hydraulic Temperature
Breaker - Auxillary F - 11 10 Sensor - Decel Pedal B-7 47 CONN 11 B-12 8 72.1 - 81.1 @ 110 ºC (230ºF)
59 9 3 19
FMI 02 Data erratic, intermittent, or incorrect. Breaker - Main F - 11 10 Sensor - Engine Speed E-2 48 31 CONN 12 B-12 9 227 - 257 @ 0-12kPa (1.74psi)
Case GND 1 LH Side E-7 11 Sensor - Left Track Speed H - 15 6 33 28 CONN 13 A-12 10
CID 1703 Proportional Solenoid Valve (Forward Left 192 ± 27.5 @ 48.3kPa (7.0psi)
Frame Ground D-3 59 Sensor - Right Track Speed G - 14 6 CONN 14 B-10 6 155-4032 Sender - Engine Oil Pressure
Drive Pump) Fuse Panel H-2 16 Solenoid - A/C COMPR Clutch F-1 51 102 ± 11 @ 276kPa (40.0psi)
CONN 15 B-10 11
Gage - Coolant Temperature D-4 12 Solenoid - Start Aid G-1 51 21.5 - 49.5 @ 552kPa (80.0psi)
FMI 03 Voltage above normal or shorted high. CONN 16 A-10 12
Gage - Engine Oil Pressure D-5 12 Solenoid - Left Motor H - 15 49
Connector List = CONN 17 D-9 13 Empty: 240 - 250
FMI 05 Voltage below normal or shorted low. Gage - Fuel Level D-5 12 Solenoid - Right Motor H - 15 50 199-6853 Sender - Fuel Level
Gage - Hydraulic Oil Temperature D-4 12 Solenoid - Left Pump Forward E-1 6 CONN 18 A-8 14 Full: 28 - 33
FMI 06 Failure mode not identifiable. Gage - Max Speed D-5 12 Solenoid - Left Pump Reverse D-1 6 Component List =
CONN 19 G-8 14 158 +/- 10.5 @ 190ºF (88ºC)
Horn - Forward G-1 13 Solenoid - Parking Brake D-2 6 CONN 20 H-8 10 208-2964 Sender - Coolant Temperature
CID 1704 Proportional Solenoid Valve (Reverse Left 50 +/- 8.6 @ 260º F (127ºC)
Hyd Temp Sender G-15 62 Solenoid - Pilot Overide D-2 6
Drive Pump) 40 27
36 CONN 21 G-7 6
Joystick Controller H-8 65 Solenoid - Right Pump Forward D-1 51 138-2622 Solenoid - Ether Aid 1.2
22 17 CONN 22 F-7 6
FMI 03 Voltage above normal or shorted high. LED Panel Light 1, 2, 3, 4, 5 C-5 14 Solenoid - Right Pump Reverse D-1 51
1 23 4 53 39 15 8 9 18 19 7 12 3E-1908 Solenoid - A/C Compressor Clutch 3.5 ± 0.15
Lamp - Dome C - 13 15 Solenoid- Engine Shutdown F-2 52 29 CONN 23 C-7 15
32 54 61 5
FMI 05 Voltage below normal or shorted low. Lamp - Fault G-8 16 Speaker - LH C - 13 53
21 CONN 24 B-7 16 199-3409 Solenoid - Engine Shutdown 0.76
26
Lamp - Frnt LF Fld A-9 17 Speaker - RH C- 13 54 CONN 25 A-7 17 179-9390 Solenoid - Pilot Override 10.3 ± 0.6 @ 25 ± 5 ºC (77ºF)
FMI 06 Failure mode not identifiable.
Lamp - Frnt LH Fld C - 10 17 Starter D-3 55 CONN 26 E-3 6 201-2171 Solenoid - Park Brake 10.16 ± .2 @ 25 ± 5 ºC (77ºF)
CID 1705 Proportional Solenoid Valve (Reverse Right Lamp - Frnt RH Fld C - 10 17 Switch - A/C Pressure F-1 56 CONN 27 E-3 6 Left Pump Fwd
Drive Pump) Lamp - Frnt RH Fld A-9 17 Switch - Blower Speed H-7 57
CONN 28 F-2 18
Lamp - Front LH Flood B - 12 18 Switch - CTR BK Pedal B-7 58 Right Pump Rev
FMI 03 Voltage above normal or shorted high. CONN 29 G-2 19
Lamp - Front RH Flood B - 12 19 Switch - Disconnect E - 11 59 192-4370 Solenoid - Left Pump Rev 6.65 Max
Lamp - No Rops Frnt Lh Fld A-9 20 Switch - Engine Oil Pressure F-2 60 The connectors shown in this chart are for harness to harness connectors.
FMI 05 Voltage below normal or shorted low. Connectors that join a harness to a component are generally located at or near Right Pump Fwd
Lamp - No Rops Frnt RH Fld A-9 20 Switch - Front Rear Wiper C - 12 61 35
the component. See the Component Location Chart. Left and Right Motor
FMI 06 Failure mode not identifiable. Lamp - OROPS Frnt LH B - 10 21 Switch - HVAC Mode H-7 57
Lamp - OROPS Frnt RH B - 10 22 Switch - Hyd Filter Bypass 1 F - 15 62 38 30 12 ¹ At room temperature unless otherwise noted.
14
CID 1706 Proportional Solenoid Valve (Reverse Right Lamp - Rear Flood D - 15 23 Switch - Hyd Filter Bypass 2 F - 15 62 68 57
34

20 Page,
Drive Pump) Link - Product A-7 24 Switch - Hyd Filter Bypass 3 F - 15 62 10 10 65 2 3 63 15
Meter - Hour H-8 25 Switch - Key B-4 12 56
FMI 03 Voltage above normal or shorted high. 5 3 46 43 41 42
7 69 1 18 51 Off Machine Switch Specification
Motor - Condensor 1 B - 15 26 Switch - Left Door Wiper D - 12 61 52
62 2
FMI 05 Voltage below normal or shorted low. Motor - Condensor 2 A-15 27 Switch - Light B-5 63 Part No. Function Actuate Deactuate Contact Position
Motor - Front Rear Washer Pump D - 15 28 Switch - Low Park Brake Press G - 15 64
33 28
14 25 47 16 60 4 13
400 kPa Max 350 ± 20 kPa Normally
58 20
FMI 06 Failure mode not identifiable. 31 16 201-4159 Low Park Brake Pressure
Motor - Front Wiper D - 12 29 Switch - Park Brake G-7 65 Related Electrical Service Manuals (58 psi Max) (50.8 ± 3 psi) Closed
Motor - Left Door Wiper B - 13 30 Switch - Right Door Wiper C - 12 61 59 17 24 37 45
CID 1707 Proportional Solenoid Valve (Left Drive Title Form Number 275 to 1750 kPa ¹ - Normally
Motor - LH DoorWasher Pump C- 1 5 31 Switch - Start Aid B-5 12 114-5333 A/C Pressure
Motor) 8 13 6 48 Power Train Testing and Adjusting RENR5539
Motor - Rear Wiper D - 13 32 Switch - Temperature Sender E-2 45 (40 to 255 psi) - Open ²
FMI 03 Voltage above normal or shorted high. Motor - RH Door Washer Pump C - 15 33 Switch - Thermostat D - 10 66
11
Power Train System Operations RENR5544 1.1 ± 0.8 ºC 2.2 ± 0.8 ºC Normally
55 3E-5464 Thermostat
Motor - Right Door Wiper A - 15 34 Timer - Engine Shutdown G-2 67
Starting Motor: 105-3133 (R3.0) SENR3828 (30 ± 1.4 ºF) (36 ± 1.4 ºF) Closed
FMI 05 Voltage below normal or shorted low. No Rops Rear Flood A - 11 35 Winch Brake Detent F - 13 68 44 9 66
64 11
Orops Rear Flood B - 11 36 Winch Spool Detent F - 13 68 Alternator: (Nippondenso G3B, K3A, L3B) SENR5841 500 kPa 500 kPa Normally
FMI 06 Failure mode not identifiable. 094-6997 Engine Oil Pressure
Platform GND E-7 37 Wiper - Right H-1 69 49 6 (72.5 psi) (72.5 psi) Closed
50 67 19
CID 1708 Proportional Solenoid Valve (Right Drive Port - Power A-7 38 7.2 ± 3 ºC 15.5 ± 3 ºC Normally
Pump) 138-2626 Temperature Sensor
45 ± 5.4 ºF 60 ± 5.4 ºF Open ²
FMI 03 Voltage above normal or shorted high. 276 kPa 207 kPa Normally
134-0404 Indicator Assembly
FMI 05 Voltage below normal or shorted low. (40.0 psi) (30.0 psi) Open ²

FMI 06 Failure mode not identifiable. ¹ With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed
condition can be maintained down to 170 kpa (25psi).
(1) For the Hydrostatic Transmission ECM, the MID is 079 . This ² Contact postion at the contacts of the harness connector.
table pertains only to diagnostic codes with a MID of 079.
 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

H1 H1 H1 H1 H1
174-6035 CHG 02
H1
H2 H2 H2 H2
D3G-D5G PHASE III
H2
H3 H3 H3 H3 H3 H3
H4 H4 H4 H4 H4
H5 H5 H5 H5
200-T12 BK-18
314-T36 PU-18 CBL-AA1 RD-00 CBL-AA1 RD-00 CBL-AA1 RD-00 CBL-AA1 RD-00 CBL-AA1 RD-00 CBL-AA1 RD-00 CBL-AA1 RD-00
T-C1 304-T2 WH-10 CBL-KK1 BK-4 CBL-KK1 BK-4 CBL-KK1 BK-4
I
1698668
1 BK-18
FUSE PANEL I
2 BK-18 MOTOR START RELAY C-C20 C-C40 Y-C1
3E-7278 ABL2CS CTRL (ECM) C-C37 1249636 1249636 1249636
109-T4 RD-10 C-C3 178-9089 C-C2 1733047
1471446 J1 J2 1607690 RD
109-T3 RD-4 709-C211 OR-18 1
BK
BATTERY
115-T13 RD-14 410-C51 WH-18 1 Arm Audible Alarm Battery + 1 126-C22 PK-16 F750-C212 YL-18 2 GROUND
200-T17 BK-18 NOTE F F853-C13 BR-18 2 Joystick Spd/Dir Input Battery - 2 202-C152 BK-18 F853-C13 BR-18 3
GN
LONGITUDE
GY
310-T16 PU-18 3 3 4 CALIBRATION 120-Y6 YL-16
384-F40 BU-10 769-C39 BU-18 4 Left Speed Sensor A 4 159-Y35 BU-14
H5 5 5 C-C38 112-Y28 PU-10
6 6 1733047 104-C120 YL-12
CDL- RD
945-C8 BR-18 7 7 709-C213 OR-18 1
BK
BATTERY 126-C164 PK-16
944-C199 OR-18 8 CDL+ 8 F750-C214 YL-18 2 GROUND 106-C70 WH-18 A9 15 A8 A7 20 A6 A5 A4 A3 A2 A1
A9 A8 A7 20 A6 A5 15 A4 A3 A2 A1
+ 10 V return YL
310-T16 PU-18 F750-C145 YL-18 9 9 C703-C14 BR-18 3
GY
LATITUDE 112-C133 PU-10
H10 200-T17 BK-18 GLOW PLUG RELAY 10 10 4 CALIBRATION A9 10 A8 A7 15 A6 A5 15 A4 A3 A2 A1
108-Y11 BU-18
4L-3913 497-C76 BU-18 11 Track Spd Snsr Supply 11 SPARE 1 SPARE 2 119-Y23 PK-14 CONDENSOR 2 LEFT WIPER
115-T15 RD-10 J764-C114 BR-18 12 Track Snsr Supply Rtn 12 C-C39 113-8491 113-8492 120-Y6 YL-16 113-8492 113-8491
709-C165 OR-18 13 + 10 V supply 13 1552264 DETENT FUSE TEHC STARTING 122-Y16 BU-16
Joystick Steering Input BK
112-C167 PU-4 C703-C14 BR-18 14 14 J764-C19 BR-18 1
GN
ACCEL/DECEL COMMON 113-8490 113-8491 113-8491 H1 158-Y34 BR-14 158-Y34 BR-14
15 15 E953-C17 GY-18 2
BR
ACCELERATE 159-Y35 BU-14 112-Y26 PU-10
833-C41 GY-18 16 Right Speed Sensor B 16 126-C119 PK-16 320-C11 OR-16 3 N.O.
T-C7 Left Speed Sensor B WH
835-C45 PU-18 17 17 126-C22 PK-16 200-C132 BK-18 4
YL
COMMON 114-C93 RD-14
3E3364 18 18 202-C152 BK-18 R981-C18 YL-18 5 105-C87 RD-18
BU
DECELERATE B9 B8 B7 20 B6 B5 B4 B3 B2 B1
WH-18 1 200-T34 BK-18 19 19 202-C151 BK-18 F773-C188 OR-18 6
RD
ACCELERATE N.O. 117-C215 RD-14
B9 B8 B7 B6 B5 B4 B3 B2 B1
WH-18 2 308-T33 YL-18 20 20 276-C3 BK-18 F774-C187 WH-18 7 DECELERATE N.O. 115-C179 RD-14 10 25
21 21 277-C121 BK-18 8 CONDENSOR 1
Battery - B9 B8 B7 B6 B5 B4 B3 B2 B1
177-T40 RD-4 22 22 202-C151 BK-18 278-C9 BK-18 124-P9 GN-14 20 10 10 113-8492
MAIN POWER RELAY
23 Battery + 23 126-C119 PK-16 279-C10 BK-18 200-P15 BK-18 SPARE 3 SPARE 4
M730-C44 YL-18 24 Govn Position Sensor 24 306-C57 GN-18 200-P13 BK-18 JOYSTICK CONTROLLER BLOWER SPEED SW 113-8490 113-8493 119-Y23 PK-14
168-7908
G745-C83 PK-18 25 Center Brake Pedal Sensor 25 308-C158 YL-18 200-C217 BK-18 183-3282 157-1361 H2 ENG SHUTDOWN TIMER KEY FWD HORN 112-Y32 PU-10
A-C6 770-C75 GN-18 26 Right Speed Sensor A 26 374-C95 PK-18 516-P3 GN-14 113-8492 113-8490 113-8490
1552272 27 27 410-C51 WH-18 517-P4 BU-14 P-C6 H3 112-Y24 PU-10
1698672 1
497-A1 BU-18 1 RD-18 + BATTERY H8 279-C10 BK-18 28 Harness Code 3 28 450-C67 YL-18 515-P2 GY-14 H24 112-Y32 PU-10 C9 C8 C7 C6 C5 25 C4 C3 C2 C1
J764-A2 BR-18 2 BK-18 GROUND LEFT TRACK SPEED SNSR C491-C115 PU-18 29 Low Brake Pressure Sw 29 451-C68 BR-18 521-Y31 YL-18 124-P9 GN-14 1 BK-14 112-C16 PU-10 112-Y28 PU-10
H 769-A3 BU-18 3 GN-18 SIGNAL A 183-4584 F774-C187 WH-18 30 Speed Decrease N.O. 30 497-C76 BU-18 614-C216 PU-18 567-P10 WH-18 6 WH-14
6
5
123-C60 WH-18 C9 10 C8 C7 C6 C5 C4 C3 C2 C1
112-Y26 PU-10 H
835-A4 PU-18 4 WH-18 SIGNAL B F773-C188 OR-18 31 Speed Increase N.O. 31 709-C165 OR-18 614-P12 PU-18 517-P4 BU-14 5 GY-14 4
102-C63 BU-18 FRONT REAR WIPER
32 Action Lamp 32 J848-C31 BU-18 899-C30 BU-18 614-P14 PU-18 516-P3 GN-14 4 GN-14 112-C153 PU-10 113-8493

CBL-AA1 RD-00
3
33 Rabbit/Turtle Indicator 33 899-C30 BU-18 915-C58 GN-18 A315-C123 WH-18 515-P2 GY-14 3 BU-14 SPARE 5
34 Action Alarm 34 J847-C29 GN-18 944-C199 OR-18 A314-C73 OR-18 C546-P6 WH-18 2 BR-14
2
C9 C8 C7 10 C6 C5 10 C4 C3 C2 C1 113-8490 122-Y16 BU-16
35 35 945-C8 BR-18 C546-P6 WH-18 H4 108-Y11 BU-18
A-C9 36 On/Off Return 36 H807-C85 YL-18 A314-C73 OR-18 J764-C74 BR-18 112-Y24 PU-10
1552269 H10 H10 276-C3 BK-18 37 Harness Code 0 37 A315-C123 WH-18 H7 LIGHTING 1 MONITORING
C959-A11 BR-18 1 BK-18 LEFT MOTOR SOLENOID 277-C121 BK-18 38 Harness Code 1 38 A958-C66 WH-18 HVAC MODE SW 113-8490 113-8490 D9 D8 D7 10 D6 D5 15 D4 D3 D2 D1
H802-A27 GY-18 2 BK-18 192-4370 278-C9 BK-18 39 Harness Code 2 Key Switch Start 39 306-C57 GN-18 C491-C115 PU-18 155-2715
450-C67 YL-18 40 Engine Speed + Left Pump Fwd Steer Sol 40 K994-C169 BU-18 C703-C14 BR-18 105-C122 RD-18 1 2
CONN 20 115-C15 RD-18
451-C68 BR-18 41 Engine Speed - 41 C920-C2 GY-18 129-C24 BU-18 D9 10 D8 D7 D6 D5 D4 D3 D2 D1 RADIO FUSE RIGHT WIPER
3
P-C7 Y-C7 Y-C8 2
H11 42 42 E953-C17 GY-18 103-C65 YL-18 113-8490 113-8491
43 43 F750-C145 YL-18 403-C71 GN-18 1698668 3E3364 1552272 124-C190 GN-14
A315-C123 WH-18 44 Park Brake Switch (N/O) Park Brake Solenoid 44 A958-C66 WH-18 F773-C188 OR-18 200-C72 BK-18 567-P10 WH-18 1 567-Y18 WH-18 1 BN-16 SPARE 6
H1 H2 H3 H4 A-C7 FUEL LEVEL SNDR 45 Center Brake Pedal Sw Fault Lamp 45 C920-C2 GY-18 F774-C187 WH-18 HOUR METER 2 2 GN-16 D9 20 D8 D7 10 D6 D5 10 D4 D3 D2 D1 113-8490
1552269 T-C2 4
199-6853 46 Reserved:Pilot Press Sw Battery - 46 F853-C13 BR-18 161-3932 3 BU-16
1552269 3
C958-A9 BU-18 1 BK-18 RIGHT MOTOR SOLENOID 47 Battery + 47 G745-C83 PK-18 521-Y31 YL-18 4 BK-16 112-C196 PU-10
H802-A10 GY-18 2 BK-18 192-4370 PK-16 1 447-T9 PK-18 48 48 H801-C168 PU-18 1
HVAC LIGHTING 2 POWER PORT FUSE
BK-18 2 200-T10 BK-18 49 Motor Solenoid Return 49 H802-C172 GY-18 H803-C28 BU-18 H15 H24 113-8492 113-8490 113-8490 BLOCK C
50 Left Motor Solenoid 50 C959-C53 BR-18 H807-C85 YL-18 BLOCK A BLOCK B (ATCH)
P-C4
51 51 J764-C114 BR-18 3T3158
52 Pump Solenoid Return 52 H801-C168 PU-18 J847-C29 GN-18 C920-C2 GY-18 1
A-C8 53 53 J848-C31 BU-18 FAULT LAMP 614-P12 PU-18 H5
1552272 A314-C73 OR-18 54 Park Brake Sw (N/C) 54 K943-C170 OR-18 3E-8679 200-P13 BK-18
497-A5 BU-18 1 RD-18 + BATTERY 55 Backup Alarm 55 321-C40 BR-18 K946-C59 OR-18 202-C1 BK-18 2 BACKLIGHT 1 447-T9 PK-18 H5 T-C10
J764-A6 BR-18 2 BK-18 GROUND RIGHT TRACK SPEED SNSR E953-C17 GY-18 56 Speed Increase N/C Battery + 56 K947-C171 YL-18 9G-0012 115-T13 RD-14 1552273
770-A7 GN-18 3 GN-18 SIGNAL A 183-4584 R981-C18 YL-18 57 Speed Decrease N/C Battery - 57 K994-C169 BU-18 CBL-KK1 BK-4 117-T1 RD-14 117-T1 RD-14 1 RD +BATTERY FA-C2
833-A8 GY-18 4 WH-18 SIGNAL B 308-C158 YL-18 58 Key Switch Run 58 M730-C44 YL-18 C-C11 308-T31 YL-18 200-T38 BK-18 2 BK GROUND 1552269
59 Pump Solenoid Rtn 59 H803-C28 BU-18 R981-C18 YL-18 9W1951 P-C5 310-T16 PU-18 308-T27 YL-18 3 GN KEY SW ENGINE SHUTDOWN TIMER 1 BK-16
60 Override Sol (Pilot) 60 915-C58 GN-18 126-C6 PK-18 A 3T3158 314-T39 PU-14 327-T30 PK-18 4 YL SOLENOID 189-4919 2 WH-16
1
61 Right Motor Solenoid 61 C958-C89 BU-18 202-C4 BK-18 B 614-P14 PU-18 H6 322-T29 GY-18 5
497-A5 BU-18 62 Right Pump Fwd sol 62 K947-C171 YL-18 H802-C61 GY-18 C 200-P15 BK-18 327-T30 PK-18 6
2
497-A1 BU-18 63 Right Pump Rev Steer Sol 63 K946-C59 OR-18 944-C7 OR-18 D SERVICE H6 383-T35 GN-14 T-C8
START AID SOL
G 769-A3 BU-18
770-A7 GN-18 443-A17 YL-16
64
65 Left Pump Rev Steer Sol
64
65 K943-C170 OR-18
945-C200 BR-18 E
F
CONNECTOR BACKLIGHT 2
9G-0012
403-T24 GN-18
441-T23 OR-18
1552267
FA-C1
3E3370
138-2622 G
H11 H11 833-A8 GY-18 H6 66 66 G C444-T26 YL-18 383-T35 GN-14 383-T35 GN-14 A 383-FA1 GN-14
835-A4 PU-18 497-A1 BU-18 A-C1 C-C17 67 67 H802-C172 GY-18 H 314-T11 PU-14 314-T11 PU-14 B 314-FA2 BU-14
C958-A9 BU-18 497-A5 BU-18 497-A26 BU-18 3E5179 1552252 68 Start Relay 68 374-C95 PK-18 J 322-T29 GY-18 322-T29 GY-18 C 322-FA3 GY-18
2
C959-A11 BR-18 106-A20 WH-18 1 106-C70 WH-18 69 Battery - 69 H802-C54 GY-18 NOTE F J764-C74 BR-18 1
200-T10 BK-18
LOW PARK BRAKE PRESS SW H802-A27 GY-18 769-A3 BU-18 200-A23 BK-18 2 200-C43 BK-18 70 Battery + 70 200-T12 BK-18 CONN 29
3
201-4159
A-C4 J764-A6 BR-18 770-A7 GN-18 H802-A28 GY-18 3 H802-C54 GY-18 7 200-T17 BK-18
H802-A10 GY-18 833-A8 GY-18 443-A17 YL-16 4 443-C33 YL-18 C-C5 CP-C1 200-C217 BK-18 C-C4 200-T34 BK-18
1552269 1552264 1958730
J764-A2 BR-18 835-A4 PU-18 497-A26 BU-18 5 497-C42 BU-18 H802-C54 GY-18 8 1429117 200-T7 BK-18 308-T18 YL-14 NOTE G
BK-18 1 C491-A25 PU-18 769-A3 BU-18 6 769-C39 BU-18 321-C40 BR-18 276-C3 BK-18 1 BK-18 614-C216 PU-18 200-T19 BK-8 COOLANT TEMP SNDR
BK-18 2 J764-A24 BR-18 770-A7 GN-18 7 770-C75 GN-18 769-C39 BU-18 202-C5 BK-18 2 BK-18 208-2964
C446-A18 PK-16
C446-A19 PK-16
C446-A29 PK-18 833-A8 GY-18
835-A4 PU-18
8
9
833-C41 GY-18
835-C45 PU-18
ABL2CS CTRL (ECM) 770-C75 GN-18
833-C41 GY-18 H14
277-C121 BK-18
278-C9 BK-18
3
4
BK-18
BK-18 PARK BRAKE SW
T-C9
1552272
C-C28
3E3376
109-T3 RD-4 T-C4
1552269 FORWARD HORN
443-A17 YL-16
C446-A19 PK-16 C491-A25 PU-18
C446-A29 PK-18
C491-A25 PU-18
10 C446-C32 PK-18
C491-C141 PU-18
(178-9089) 835-C45 PU-18
C958-C89 BU-18
279-C10 BK-18 5 HARNESS 190-8478 314-T39
322-T29
PU-14
GY-18
1 314-C47 PU-12
322-C64 GY-12 304-T2 WH-10
441-T23 OR-18
200-T6 BK-18
1 BK-16
BK-16
179-6289
11 6 CODE PLUG 2 2

HOOD
T°
C446-A18 PK-16 C958-A9 BU-18 C958-A9 BU-18 12 C958-C89 BU-18 276-C3 BK-18 C959-C53 BR-18 7 A315-C123 WH-18 327-T30 PK-18 3 327-C181 PK-18
HYD TEMP SNDR C491-A25 PU-18 C959-A11 BR-18 277-C121 BK-18 8 A314-C73 OR-18 383-T35 GN-14 4 383-C182 GN-14
7W-9943 J764-A24 BR-18 CONN 9 H8 278-C9 BK-18 308-T25 YL-18
CONN 19 CONN 21
H802-A10 GY-18 H802-A28 GY-18 279-C10 BK-18 CBL-AA1 RD-00 CBL-AA1 RD-00
443-A17 YL-16 H802-A27 GY-18
A-C11 C-C19 H6
H8 308-C158 YL-18
410-C51 WH-18
321-C40 BR-18
769-C39 BU-18
LEFT HAND CONSOLE 384-F40 BU-10
°T
J764-A24 BR-18 1552267 3E3370 450-C67 YL-18 770-C75 GN-18 H7 105-C122 RD-18 H7 T-C3 C-C1 447-T9 PK-18 109-T3 RD-4
J764-A2 BR-18 C959-A11 BR-18 A C959-C53 BR-18 H6 451-C68 BR-18 833-C41 GY-18 124-P9 GN-14 1907612 1552253 112-C167 PU-4
J764-A6 BR-18 J764-A16 BR-18 B J764-C113 BR-18 H10 497-C76 BU-18 835-C45 PU-18 H14 114-C93 RD-14 126-C6 PK-18 C444-T26 YL-18 1 C444-C35 YL-18 327-C181 PK-18 115-T13 RD-14
J764-A16 BR-18 C 709-C165 OR-18 C958-C89 BU-18 126-C164 PK-16 200-C132 BK-18 117-T1 RD-14 2 117-C215 RD-14 383-C182 GN-14 109-T3 RD-4 200-T34 BK-18
CONN 8 H10 769-C39 BU-18 C959-C53 BR-18 200-P13 BK-18 H6 308-T31 YL-18 3 308-C128 YL-18 112-C167 PU-4 200-T17 BK-18
HYD FILTER BYPASS SW 1 770-C75 GN-18 H802-C54 GY-18 126-C22 PK-16 126-C6 PK-18 200-P15 BK-18 441-T23 OR-18 4 441-C62 OR-18 115-C12 RD-14 115-T13 RD-14 200-T12 BK-18 H5
134-0404 833-C41 GY-18 H6 126-C119 PK-16 200-C217 BK-18 403-T24 GN-18 5 403-C197 GN-18 117-C215 RD-14 117-T1 RD-14 304-T2 WH-10
H12 106-A20 WH-18 835-C45 PU-18 200-T10 BK-18 200-C72 BK-18 6 308-C128 YL-18 200-T12 BK-18 308-T33 YL-18 F-C17 N-C5
C446-A19 PK-16 200-A23 BK-18 BREAKER PLATFORM H8 944-C199 OR-18
945-C8 BR-18
106-C70 WH-18
200-T10 BK-18
200-C134 BK-12
200-C72 BK-18
202-C4 BK-18
202-C1 BK-18
7
8
310-C176 PU-18
314-C47 PU-12 H21
200-T7 BK-18
200-T34 BK-18
310-T16 PU-18
384-F40 BU-10 521-F16 YL-18
3E3364
1
1552269
521-N2 YL-18
A-C10 A314-C73 OR-18 200-C43 BK-18 200-C25 BK-14 202-C5 BK-18 9 322-C64 GY-12 200-T17 BK-18 521-F16 YL-18 522-F17 WH-18 2 522-N7 WH-18 N-C3
1552269 101-T8 RD-10 115-T14 RD-10 115-T13 RD-14 A315-C123 WH-18 443-C33 YL-18 200-C148 BK-14 276-C3 BK-18 447-T9 PK-18 10 447-C34 PK-18 403-C197 GN-18 304-T2 WH-10 522-F17 WH-18 1552269
40
106-A22 WH-18 115-T15 RD-10 C491-C115 PU-18 447-T9 PK-18 277-C121 BK-18 115-T13 RD-14 115-C12 RD-14 441-C62 OR-18 308-T25 YL-18 314-T36 PU-18 521-N2 YL-18
F 200-A13 BK-18
1
2
RD-20
RD-20 AUXILLARY BREAKER C703-C14 BR-18 497-C42 BU-18 200-C43 BK-18 278-C9 BK-18 310-T16 PU-18
11
12 310-C176 PU-18 447-C34 PK-18 308-T31 YL-18
CONN 28
589-N5 GN-18
1
2
BK-18
BK-18 2
3
F
1
HYD FILTER BYPASS SW 2 171-2204 E953-C17 GY-18 C446-C32 PK-18 202-C146 BK-14 279-C10 BK-18 C444-C35 YL-18
134-0404 NOTE C F750-C145 YL-18 C491-C141 PU-18 202-C152 BK-18 202-C204 BK-18 320-C11 OR-16 CONN 22 308-T33 YL-18 314-T39 PU-14 314-T11 PU-14
106-A20 WH-18 WINCH SPOOL DETENT F773-C188 OR-18 H807-C94 YL-18 202-C151 BK-18 403-C71 GN-18 322-T29 GY-18 F400-F10 GY-18 ENG OIL PRESS SW
C446-A18 PK-16 137-9754 F774-C187 WH-18 J764-C113 BR-18 202-C204 BK-18 515-P2 GY-14 117-T1 RD-14 094-6997 A/C PRESSURE SW
BACKUP ALARM F853-C13 BR-18 202-C203 BK-18 516-P3 GN-14 310-T16 PU-18 114-5333
C446-HF1 PK-16 H12 123-6449 C-C18A C-C18 G745-C83 PK-18 202-C1 BK-18 517-P4 BU-14 314-T39 PU-14 200-T6 BK-18 NOTE E
200-A23 BK-18 3E3364 1552269 109-TA1 RD-4 H10 J764-C114 BR-18 374-C95 PK-18 202-C4 BK-18 521-Y31 YL-18 322-T29 GY-18 200-T7 BK-18 200-T38 BK-18
A-C2 C-C6 N-C2
BK-18 1 321-C40 BR-18 109-T3 RD-4 177-T40 RD-4 M730-C44 YL-18 9X1054 2 5
H807-C52 YL-18 202-C5 BK-18 614-P12 PU-18 115-C12 RD-14 327-T30 PK-18
1552269 BK-18 2 H807-C94 YL-18
90 90
R981-C18 YL-18 279-C10 BK-18 614-C216 PU-18 117-C215 RD-14 383-T35 GN-14 308-T25 YL-18 1552269
HYD FILTER BYPASS SW 3 106-A21 WH-18 1 RD-20 MAIN BREAKER 4 277-C121 BK-18 614-P14 PU-18 H7 308-C128 YL-18 384-F40 BU-10 308-T33 YL-18 589-N4 GN-18 1 BK-14
134-0404 200-A14 BK-18 2 RD-20 CONN 7 ALTERNATOR BREAKER 171-2211 104-C120 YL-12 278-C9 BK-18 709-C213 OR-18 310-C176 PU-18 441-T23 OR-18 327-F21 PK-18 ENG SHUTDOWN SOL 522-N1 WH-18 2 BK-14
1 CONN 26
171-2211 NOTE C 3 306-C57 GN-18 709-C211 OR-18 CBL-KK1 BK-4 314-C47 PU-12 308-T31 YL-18 308-T27 YL-18 199-3409
C446-HF1 PK-16 CBL-KK1 BK-4 NOTE C 109-T4 RD-10 308-C158 YL-18 200-C134 BK-12 322-C64 GY-12 308-T18 YL-14 C-C9 F-C5
WINCH BRAKE DETENT WHEN BACKUP ALARM ATTACHMENT IS USED 314-C47 PU-12 202-C146 BK-14 403-C197 GN-18 H21 1552254 1907613 A/C COMPR CLUTCH SOL
137-9754 REMOVE C-C18A CAP CONNECTOR CBL-AA1 RD-00 STARTING RELAY H15 308-C128 YL-18 200-P31 BK-14 441-C62 OR-18 327-T30 PK-18 383-C182 GN-14 1 383-F39 GN-14 3E-1908
AND ADD 123-6449 BACKUP ALARM. 115-1615 308-C138 YL-18 200-X3 BK-10 447-C34 PK-18 383-T35 GN-14 451-C68 BR-18 2 451-F11 BR-18
CASE CBL-AA2 RD-2 CBL-AA2 RD-2
H6 320-C11 OR-16
314-C47 PU-12
320-C11 OR-16 709-C183 OR-18
200-Y29 BK-8 C444-C35 YL-18 441-T23 OR-18 464-C46 GY-18
521-C21 YL-18
3
4
464-F6 GY-16
521-F16 YL-18 F-C14
N-C4
1552269
H4 H4 114-C92 RD-18 322-C64 GY-12 709-C165 OR-18 200-Y8 BK-16 CBL-KK2 BK-4 112-C167 PU-4 109-T3 RD-4 522-C191 WH-18 5 522-F17 WH-18 1552269 589-N6 GN-18 1
C-C7 MUR440
9X1054 2 5
374-C95 PK-18 944-C7 OR-18 200-Y14 BK-16 NOTE C 200-C148 BK-14 200-C148 BK-14 327-C181 PK-18 6 327-F21 PK-18 383-F39 GN-14 1 BK-16 T
TEMP SNDR SW 522-N3 WH-18 2
H3 H3 H4 CBL-FF3 RD-2 945-C200 BR-18 200-Y49 BK-8 PLATFORM 200-T10 BK-18 304-T2 WH-10 F400-C36 GY-18 7 F400-F10 GY-18 200-F14 BK-14 2 BK-16 138-2626
4 114-C92 RD-18 410-C51 WH-18 A314-C73 OR-18 GND 447-T9 PK-18 308-T25 YL-18 H801-C168 PU-18 8 H801-F30 PU-18 °T NOTE A A/C ARC SUPPRESSOR
H2 H2 H3 CBL-FF2 RD-00 1
114-C93 RD-14 443-C33 YL-18 A315-C123 WH-18 450-C67 YL-18 327-C181 PK-18 K994-C169 BU-18 9 K994-F22 BU-18 106-8704
3 NOTE F 447-T9 PK-18 C546-P6 WH-18 464-C46 GY-18 383-C182 GN-14 K943-C170 OR-18 10 K943-F23 OR-18
H1 H1 H2 CBL-HH2 BK-00 497-C76 BU-18 C703-C14 BR-18 451-C68 BR-18 384-F40 BU-10 K947-C171 YL-18 11 K947-F24 YL-18
H1 HORN RELAY
322-C64 GY-12 497-C42 BU-18 C920-C2 GY-18
E953-C17 GY-18 CBL-KK2 BK-4 200-T19 BK-8
521-C21 YL-18
522-C191 WH-18
403-T24 GN-18
450-C67 YL-18
K946-C59 OR-18 12 K946-F25 OR-18 A/C COMPRESSOR(ATCH)
CBL-HH1 BK-00 115-1615 915-C58 GN-18 451-C68 BR-18 F-C16
RADIO 497-C207 BU-18 NOTE F F750-C214 YL-18 A958-C66 WH-18 464-C46 GY-18 C-C29
Y-C4 173-6532 1552264 3E3388 ENG OIL PRESS SNDR
1673692
J-C14 105-J39 RD-18 NEG POS NEG POS
200-X5 BK-16 497-C208 BU-18 F750-C212 YL-18 F400-C36 GY-18 521-C21 YL-18 464-F6 GY-16 155-4032
1673693 105-J20 RD-18 105-J38 RD-18 105-J38 RD-18 85 86 X-C1 450-C67 YL-18 112-C167 PU-4 F931-C37 PK-18 522-C191 WH-18 200-C148 BK-14 1 200-F14 BK-14
105-Y10 RD-18 1 105-J20 RD-18 108-J37 BU-18 ANTENNA LEAD 3E-5519 451-C68 BR-18 115-C12 RD-14 NOTE C H801-C168 PU-18 915-C58 GN-18 450-C67 YL-18 2 450-F12 YL-18
BATTERY 2 HD BATTERY 1 HD
200-Y15 BK-14 2 200-J9 BK-14 108-J37 BU-18 119-J40 PK-14 9U-8746 709-C165 OR-18 F750-C184 YL-18 117-C215 RD-14 CASE GND 1 H802-C61 GY-18 A958-C66 WH-18 A958-C66 WH-18 3 A958-F35 WH-18
E E
87
EROPS 200-Y52
108-Y11
BK-18
BU-18
3
4
200-J35 BK-18
108-J37 BU-18
119-J24 PK-16
120-J23 YL-16
J-C2 J-C20
1552264 3E3388 ANTENNA
9X-3404
CBL-FF1 RD-00
9X-3404
C547-X11 OR-12 30
899-C30 BU-18
915-C58 GN-18
F750-C145 YL-18 200-T10 BK-18
200-C148 BK-14
LH SIDE K943-C170 OR-18
K946-C59 OR-18
C444-T26 YL-18
F400-C36 GY-18
F931-C37 PK-18
915-C58 GN-18
4
5
F931-F36 PK-18
915-F31 GN-18
(ATCH) 5 122-J1 BU-16 508-J10 PU-18 1 WH/BK FLH SP -
87A
945-C200 BR-18 F773-C188 OR-18 308-C128 YL-18 K947-C171 YL-18 F931-C37 PK-18 H802-C61 GY-18 6 H802-F32 GY-18 F-C3
119-Y23 PK-14
120-Y7 YL-16
6
7
119-J41 PK-14
120-J23 YL-16
119-J41 PK-14
119-J3 PK-16
119-J40 PK-14
119-J24 PK-16
200-J18 BK-18
200-J14 BK-18
509-J11 WH-18
200-J14 BK-18
2
3
WH
BK
FLH SP +
GROUND
HVY DTY BAT. (ATCH) HIGH SPD RLY
3E-9362
944-C7 OR-18 F774-C187 WH-18
F853-C13 BR-18
310-C176 PU-18
314-C47 PU-12
K994-C169 BU-18
H803-C28 BU-18
H801-C168 PU-18
H802-C61 GY-18
H803-C28 BU-18 7
8
H803-F41 BU-18
451-F11 BR-18
1552269
1 BK-18 ENG SPEED SNSR
122-Y51 BU-16 8 122-J1 BU-16 200-J19 BK-18 4 NC 944-C201 OR-18 J764-C74 BR-18 322-C64 GY-12 K943-C170 OR-18 CONN 27 450-F12 YL-18 2 WH-18 189-5746
9 200-J26 BK-16 105-J38 RD-18 5 YL B+ MEM(NOTE D) 125-X13 OR-12 945-C202 BR-18 J764-C19 BR-18 403-C197 GN-18 K946-C59 OR-18
H19 10 120-J23 YL-16 503-J4 BR-16 108-J37 BU-18 6 3A RD B+(12V) R981-C18 YL-18 441-C62 OR-18 K947-C171 YL-18 384-F40 BU-10
11 122-J1 BU-16 504-J5 YL-16 511-J16 BR-18 7 GY/BK FRH SP - 945-C8 BR-18 447-C34 PK-18 K994-C169 BU-18
12 506-J34 PU-18 512-J17 GN-18 8 GY FRH SP +
30
112-X2 PU-4 944-C199 OR-18 112-C167 PU-4 447-T9 PK-18 H803-C28 BU-18 304-T2 WH-10 384-F40 BU-10
13 523-J21 BR-16 GN/BK RLH SP - 115-C12 RD-14 450-C67 YL-18
506-Y12 PU-18 14 506-J34 PU-18 524-J29 BU-16 CONN 10
GN RLH SP + DISCONNECT SW HVAC BRKR A314-C73 OR-18 117-C215 RD-14 451-C68 BR-18 304-T2 WH-10
523-Y36 BR-16 15 523-J21 BR-16 200-J35 BK-18 200-J19 BK-18 525-J28 GY-16 VI/BK RRH SP - 7N-0718 X-C4 147-1773 A315-C123 WH-18 200-T10 BK-18 464-C46 GY-18
524-Y2 BU-16 16 524-J29 BU-16 200-J18 BK-18 526-J31 YL-16 VI RRH SP + 1779646 A958-C66 WH-18 200-C134 BK-12 521-C21 YL-18 F-C19
525-Y17 GY-16 17 525-J28 GY-16 527-J22 GN-16 WH/RD-12 1 C446-C32 PK-18 200-Y14 BK-16 522-C191 WH-18 1552269
526-Y37 YL-16 18 526-J31 YL-16 528-J30 PK-16 WHEN RADIO ATTACHMENT IS USED MOTOR BK-12 2 C491-C115 PU-18 200-Y8 BK-16 915-C58 GN-18 K994-F22 BU-18 1
527-Y39 GN-16 19 527-J22 GN-16 506-J34 PU-18 529-J33 WH-16 REMOVE J-C20 CAP CONNECTOR RADIO CBL-EE BK-00 CBL-AA2 RD-2 C491-C141 PU-18 200-Y49 BK-8 A958-C66 WH-18 ENG OIL PRESS GAGE MAX SPD GAGE COOLANT TEMP GAGE G S
H803-F41 BU-18 2
528-Y38 PK-16 20 528-J30 PK-16 523-J21 BR-16 530-J32 WH-18 AND ADD 173-6532 RADIO GP 173-6532 CBL-AA1 RD-00 BLOWER 200-X3 BK-10 C444-C35 YL-18 154-7488 191-0538 201-2408
529-Y40 WH-18 21 529-J33 WH-16 524-J29 BU-16 607-J12 PK-18 NEG POS
168-2313 200-P31 BK-14 F400-C36 GY-18 LEFT PUMP FWD SOL
MTR BAT
530-Y45 WH-18 22 530-J32 WH-18 525-J28 GY-16 614-J13 PU-18 C547-X4 OR-14 C491-C137 PU-18 200-C148 BK-14 F931-C37 PK-18 123-E19 WH-18 E-C1 E-C10 E-C3 CBL-AA1 RD-00 192-4370
607-Y44 PK-18 23 607-J12 PK-18 526-J31 YL-16 202-C146 BK-14 H801-C168 PU-18 LAMP 3 1141749 LAMP 2 1141749 LAMP 4 1141749 6 GLOW PLUGS
IGN IGN IGN
614-Y1 PU-16 24 614-J13 PU-18 527-J22 GN-16 GND BATTERY 1
276-C3 BK-18 308-C128 YL-18 H802-C61 GY-18 7X9065 7X9065 7X9065 MOTOR 107-3659
25 528-J30 PK-16 J-C3 MOTOR H C703-C14 BR-18 314-C47 PU-12 K943-C170 OR-18 614-E16 PU-18 F-C20
9X-3404 SEND SEND SEND STARTER
26 529-J33 WH-16 501-J6 GN-16 1552272 C920-C2 GY-18 322-C64 GY-12 K946-C59 OR-18 H801-F30 PU-18 1552269
105-3133
T°
27 530-J32 WH-18 200-J26 BK-16 1 BK X-C2 P-C2 E953-C17 GY-18 403-C197 GN-18 K947-C171 YL-18 K946-F25 OR-18 1

CBL-GG BKCBL-00
GND GND GND
28
29
607-J12
614-J13
PK-18
PU-18
119-J24 PK-16
500-J7 BR-16
4
2
YL
GN
B+ P BAT. BOX BLOWER UNIT RES C546-X6 WH-16
3E3382
1
1552273
C546-P6 WH-18
F750-C145 YL-18
F773-C188 OR-18
447-T9 PK-18
450-C67 YL-18
K994-C169 BU-18
H803-C28 BU-18 200-E11 BK-18
H801-F26 PU-18
H801-F29 PU-18
H801-F28 PU-18 2

30 500-J7 BR-16 501-J6 GN-16 3 RD 139-3900 2 F774-C187 WH-18 451-C68 BR-18 464-E21 GY-16 H801-F28 PU-18 RIGHT PUMP REV SOL
31 515-X9 GY-14 3 515-P2 GY-14 F853-C13 BR-18 521-C21 YL-18 192-4370
CONN 3 200-J15 BK-18 FRNT WIPER MOTOR 200-X10 BK-18 516-X8 GN-14 4 516-P3 GN-14 G745-C83 PK-18 522-C191 WH-18 614-E60 PU-18 H803-F41 BU-18
119-J3 PK-16 200-J9 BK-14 200-J14 BK-18 179-4809 517-X7 BU-14 5 517-P4 BU-14 H801-C168 PU-18 915-C58 GN-18 200-E61 BK-18 K946-F25 OR-18
H19 200-J26 BK-16 CBL-CC BK-00 200-X12 BK-12 522-X1 WH-18 6 522-P5 WH-18 H802-C61 GY-18 A958-C66 WH-18 F750-E58 YL-18 K947-F24 YL-18 F-C18
200-J15 BK-18 H803-C28 BU-18 F931-C37 PK-18 899-E34 BU-18 K943-F23 OR-18 1552269
200-J2 BK-16 105-J39 RD-18 CONN 17 H807-C85 YL-18 H801-C168 PU-18 709-E59 OR-18 K994-F22 BU-18 K943-F23 OR-18 1

D CBL-KK1 BK-4 H802-C61 GY-18 H801-F26 PU-18 2

D
ROOF
T°
504-J5 YL-16 LEFT DOOR WIPER SW CASE GND 2 H807-C52 YL-18 H807-C84 YL-18 H803-C28 BU-18 614-E17 PU-18 614-E17 PU-18
(Dimensions: 39 inches x 24 inches)

Y-C2 503-J4 BR-16 112-6174 RH SIDE THERMOSTAT SW H807-C94 YL-18 K946-C59 OR-18 200-E13 BK-18 200-E13 BK-18 LEFT PUMP REV SOL

BK-16 1
1552269
607-Y41 PK-18
(ATCH) 200-J2 BK-16 NOTE C 3E-5464
200-X3 BK-10
J764-C210 BR-18
J764-C74 BR-18
K947-C171 YL-18
K994-C169 BU-18
441-E23
123-E20
OR-18
WH-16
441-E23
123-E20
OR-18
WH-16
PILOT OVERRIDE SOL
179-9390
192-4370
GND
BK-16 2 200-Y13 BK-18 J-C4 MOTOR H J-C5 CBL-AA1 RD-00 J764-C113 BR-18 J764-C19 BR-18 K943-C170 OR-18 102-E49 BU-18 F-C11 F-C21

105-Y10 RD-18 200-J2 BK-16

1552272
1 BK T°
1552264
1 RD
H B B
HVAC BOX J764-C114 BR-18
J764-C209 BR-18
124-C190 GN-14
103-E9 YL-18
105-E27 RD-18
200-E6 BK-18
443-E22 YL-16
200-E6 BK-18
443-E22 YL-16 FRAME GND 2 915-F31 GN-18
1552267
A RD-18 K947-F24 YL-18
1552269
1
REAR FLOOD LAMP
201-1423
108-Y11 BU-18
119-Y23 PK-14
119-J3
503-J4
PK-16
BR-16
4
2
YL
GN
B+ P 120-J23 YL-16 2
3
RD
(ATCH) J847-C29 GN-18
J848-C31 BU-18
123-E43 WH-18 123-E18 WH-18
614-E15 PU-18
123-E18 WH-18
614-E15 PU-18 NOTE C
A958-F35 WH-18
F931-F36 PK-18
H802-F32 GY-18 B
C
RD-18 H801-F29 PU-18 2

504-J5 YL-16 3 RD 525-J28 GY-16 4 WH

L
112-C16 PU-10 K943-C170 OR-18 114-C93 RD-14 123-E18 WH-18 915-F31 GN-18 PARK.BK SOL RIGHT PUMP FWD SOL
Y-C18 120-Y7 YL-16 524-J29 BU-16 5 YL H4 H4 H4 115-C15 RD-18 K946-C59 OR-18 123-E4 WH-18 H802-F32 GY-18 201-2171 192-4370
P W
1237615 REAR WIPER MOTOR 523-J21 BR-16 6 BU K947-C171 YL-18 200-C25 BK-14 123-E19 WH-18 123-E20 WH-16 447-E5 PK-16 F-C12
1 506-Y12 PU-18 120-Y6 YL-16 179-4812 529-J33 WH-16 7 BR K994-C169 BU-18 123-E40 WH-18 123-E19 WH-18 123-E4 WH-18 1552269
MOTOR C-C16 E-C14
2 200-Y46 BK-18 8 H3 H3 112-Y24 PU-10 M730-C44 YL-18 1673692 123-E20 WH-16 123-E29 WH-18 E-C4 A958-F35 WH-18 A958-F33 WH-18 1 GN-18
120-Y43 YL-16 112-Y32 PU-10 R981-C18 YL-18 310-C176 PU-18 1673693 123-E29 WH-18 123-E18 WH-18 LAMP 1 E-C2 LAMP 5 1141749 F931-F34 PK-18 2 GN-18

-
+
IGN IGN
FRONT REAR WASHER PUMP DOME LAMP
H2 H3 112-Y28 PU-10 H13 441-C62 OR-18 102-C63 BU-18 1 102-E49 BU-18 123-E4 WH-18 7X9065 1141749 7X9065 403-T24 GN-18
122-Y51 BU-16 112-Y26 PU-10 104-C120 YL-12 464-C46 GY-18 103-C65 YL-18 2 103-E9 YL-18 200-E7 BK-18 614-E3 PU-18 SEND
F-C13 308-T25 YL-18
6T-1375 4M-3601 SEND 1552269
H2 H2 126-C164 PK-16 H25 447-C34 PK-18 105-C125 RD-18 3 105-E27 RD-18 200-E41 BK-18 200-E61 BK-18 C444-T26 YL-18
FRONT REAR WIPER SW 106-C70 WH-18 C444-C35 YL-18 4 200-E2 BK-18 GND GND A958-F37 WH-18 1
Y-C20 122-Y16 BU-16 WH 132-7084 H1 F750-C184 YL-18 F400-C36 GY-18 123-C60 WH-18 5 123-E43 WH-18 200-E6 BK-18 F931-F36 PK-18 F931-F38 PK-18 2
1237615 122-Y50 BU-16 BK 200-C38 BK-18 6 200-E41 BK-18 200-E13 BK-18 200-E13 BK-18 200-E2 BK-18 L1 L2 L3
1 529-Y40 WH-18 200-Y25 BK-16 H9 H9 H9 306-C57 GN-18 7 306-E26 GN-18 200-E61 BK-18 200-E11 BK-18 ARC SUPPRESSOR T-C5

1
2
3
MOTOR P W 1073134
2 200-Y48 BK-18 104-C120 YL-12 709-C183 OR-18 308-C138 YL-18 8 308-E24 YL-18 200-E53 BK-18 410-E12 WH-18 FUEL LEVEL GAGE HYD OIL TEMP GAGE 106-8704 L I R
H19 J-C1 106-C70 WH-18 310-C176 PU-18 310-E37 PU-18 200-E11 BK-18 441-E23 OR-18 ALTERNATOR
RENR5807-01

LA-C1 9 153-0455 154-7487

LH DOOR WASHER PUMP
200-Y52 BK-18
200-Y15 BK-14 108-LA1 RD-18
3E3382
1
1552273
105-J39 RD-18 J-C8
H 126-C164 PK-16 H25
F931-C37 PK-18
310-C176 PU-18
441-C62 OR-18
441-C62 OR-18
443-C33 YL-18
10
11
441-E23 OR-18
443-E22 YL-16
200-E2 BK-18
200-E38 BK-18
443-E22 YL-16
447-E5 PK-16
VALVE MANIFOLD B 55AMP 105-2811 STD
6T-1375
H18 523-Y36 BR-16
524-Y2 BU-16
200-LA2
511-LA3
BK-18
BR-18
2
3
200-J15
511-J16
BK-18
BR-18 506-J34 PU-18
1552273
6 BR BW VC-C1 VC-C3 102-C63 BU-18 H13
447-C34 PK-18
464-C46 GY-18
447-C34 PK-18
464-C46 GY-18
12
13
447-E5 PK-16
464-E21 GY-16
200-E7 BK-18
200-E6 BK-18
464-E21 GY-16
614-E3 PU-18
L4 L5
200-6492 G 90AMP 105-2814 ATCH
3E3364 1552269 110AMP 203-5492 ATCH
525-Y17 GY-16 512-LA4 GN-18 4 512-J17 GN-18 500-J7 BR-16 4 BU B 103-C65 YL-18 C444-C35 YL-18 14 614-E60 PU-18
Y-C19
1237615
526-Y37 YL-16
527-Y39 GN-16
508-LA5
509-LA6
PU-18
WH-18
5
6
508-J10
509-J11
PU-18
WH-18
501-J6 GN-16
504-J5 YL-16
2
5
YL
YL
B1
TO CONNECTOR M-C2
1
2
607-VC1 PK-18
200-VC2 BK-18
607-VC1 PK-18
200-VC6 BK-18
1
2
BK-16
BK-16
516-P3 GN-14
105-C193 RD-18
F400-C36 GY-18 607-C26 PK-18
614-C194 PU-18
15
16
607-E36 PK-18
614-E42 PU-18
306-E26 GN-18
308-E24 YL-18
614-E15 PU-18
614-E16 PU-18
E-C7
1552252 LAMP COLOR FUNCTION
109-T3 RD-4
308-T25 YL-18
ENGINE
MOTOR
1 530-Y45 WH-18 528-Y38 PK-16 H17 503-J4 BR-16 3 BU LOC (B-10) 105-C87 RD-18 899-C30 BU-18 17 899-E34 BU-18 310-E37 PU-18 614-E17 PU-18 123-E29 WH-18 1 RD 403-T24 GN-18 109-T3 RD-4
2 200-Y47 BK-18 614-Y1 PU-16 CONN 6 119-J40 PK-14 1 RD 102-C63 BU-18 C444-C35 YL-18 18 C444-E32 YL-18 410-E12 WH-18 709-E59 OR-18 J848-E31 BU-18 10 DKBU L1 RED ENGINE OIL PRESSURE C444-T26 YL-18
607-Y44 PK-18 FRNT LH FLD LMP 105-C122 RD-18 103-C65 YL-18 C446-C32 PK-18 C446-E33 PK-18 441-E23 OR-18 899-E34 BU-18
C C
19 4

RH DOOR WASHER PUMP

201-1422 105-C125 RD-18 105-C125 RD-18 C491-C137 PU-18 20 C491-E14 PU-18 443-E22 YL-16 C446-E33 PK-18 C446-E33 PK-18 3 BU L2 RED HYSTAT FILTER BY PASS
6T-1375 530-Y45 WH-18 H1
105-C205 RD-18 123-C60 WH-18 F400-C36 GY-18 21 F400-E30 GY-18 447-E5 PK-16 C444-E32 YL-18 C444-E32 YL-18 7 PK
529-Y40 WH-18 509-LA6 WH-18 + VC-C2 VC-C4 200-C38 BK-18 22 464-E21 GY-16 C491-E14 PU-18 F400-E30 GY-18 5 WH
506-Y12 PU-18 508-LA5 PU-18 - P1 3E3364 1552269 306-C57 GN-18 23 607-E36 PK-18 F400-E30 GY-18 C491-E14 PU-18 6 GN L3 RED ACTION LAMP
1 614-VC3 PU-18 614-VC3 PU-18 1 BK-16 308-C138 YL-18 24 F750-E58 YL-18 J847-E35 GN-18 8 YL
LH SPEAKER TO CONNECTOR M-C3 2 200-VC4 BK-18 200-VC5 BK-18 2 BK-16 112-X2 PU-4 410-C51 WH-18 25 J847-E35 GN-18 9 PU LED PANEL W/ ALARM L4 RED PARKING BRAKE
6T-7695 LOC (B-10) 103-C65 YL-18 112-C167 PU-4 443-C33 YL-18 J847-C29 GN-18 26 J847-E35 GN-18 614-E42 PU-18 J848-E31 BU-18 410-E12 WH-18 11 GY 184-4327
102-C63 BU-18 607-C26 PK-18 J848-C31 BU-18 27 J848-E31 BU-18 103-E9 YL-18 200-E7 BK-18 2 BK NOTE J L5 RED ALTERNATOR
CONN 2 FRNT RH FLD LMP 104-C120 YL-12 112-Y32 PU-10 614-C194 PU-18 28 614-E51 PU-18 12
W-C1 Y-C6 159-Y35 BU-14 RIGHT DOOR WIPER SW 201-1422 105-C87 RD-18 112-Y24 PU-10 709-C183 OR-18 410-C51 WH-18 29 410-E12 WH-18 614-E39 PU-18 607-E36 PK-18 L6 RED NOT USED
1779649 1779654 200-Y47 BK-18 112-6174 OROPS SWEEPS LIGHTING (ATCH) 106-C70 WH-18 899-C30 BU-18 709-C183 OR-18 30 709-E59 OR-18 614-E15 PU-18 308-E24 YL-18
158-W8 BR-12 1 158-Y34 BR-14 H18 200-Y46 BK-18 512-LA4 GN-18 + 112-C153 PU-10 112-Y26 PU-10 C446-C32 PK-18 F750-C184 YL-18 31 F750-E58 YL-18 614-E17 PU-18 306-E26 GN-18 614-E51 PU-18
200-W10 BK-14 2 200-Y3 BK-14 158-Y34 BR-14 511-LA3 BR-18 - 112-C133 PU-10 112-Y28 PU-10 C491-C137 PU-18 105-E27 RD-18 607-E36 PK-18
159-W9 BU-12 3 159-Y35 BU-14 200-Y13 BK-18 J-C6 112-C196 PU-10 F750-C184 YL-18 614-E10 PU-18 200-E53 BK-18
1552264 H B B CONN 23
200-W11 BK-14 4 200-Y4 BK-14 200-Y4 BK-14 RH SPEAKER 115-C179 RD-14 112-C153 PU-10 J847-C29 GN-18 102-E49 BU-18 E-C6 1
200-Y48 BK-18 6T-7695 1 RD 117-C215 RD-14 112-C196 PU-10 J848-C31 BU-18 614-E1 PU-18 1429117 2 E-C5
200-Y3 BK-14 122-J1 BU-16 2 RD 123-C60 WH-18 614-E1 PU-18 123-E40 WH-18 103-E9 YL-18 3
2 MOM 1429117
R
W-C6 Y-C5 521-Y5 YL-18 3 M-C1 614-E16 PU-18 200-E38 BK-18 308-E24 YL-18
3E3364
1
1552269 607-Y41 PK-18 HEADLINER 528-J30
527-J22
PK-16
GN-16
4
5
WH
YL
L
1
3E3382 M-C2
1552269
H2 124-P9 GN-14 PWR STUD 2
187-8674
614-E3 PU-18
614-E51 PU-18
614-E39 PU-18
310-E37 PU-18 102-E49 BU-18
5 4
7
3 C OFF

(ATCH)
P W S ON
521-W12 YL-18 2 521-Y5 YL-18 526-J31 YL-16 6 BU
CONNECT TO
2 200-M1 BK-16 607-M4 PK-18 1 BK-16 NOTE C 614-E60 PU-18 9 6
306-E26 GN-18 B ST
530-J32 WH-18 7 BR 3 200-M5 BK-18 2 BK-16 124-C190 GN-14 112-C133 PU-10 200-E53 BK-18 105-E27 RD-18
CONN 1 H17 8 C-C8 LOC (A-12) 4 607-M2 PK-18 126-C164 PK-16 112-C16 PU-10 F931-AC1 PK-16 709-E59 OR-18 7
10 8
5 614-M3 PU-18 129-C24 BU-18 114-C93 RD-14 899-E34 BU-18 614-E1 PU-18 8
KEY SW
6 OROPS FRNT LH FLD 114-C93 RD-14 C444-E32 YL-18 9G-7641
521-W12 YL-18 201-1422 115-C15 RD-18 115-C12 RD-14 C-C35 AC-C1 C446-E33 PK-18
200-W10 BK-14 115-C179 RD-14 1552269 3E3364 C491-E14 PU-18 LIGHT SW START AID SW
159-W9 BU-12 108-Y11 BU-18 M-C4 M-C3 117-C215 RD-14 F931-C37 PK-18 1 F400-E30 GY-18 180-6615 180-6614
200-W11 BK-14 119-Y23 PK-14 1552269 1552269 123-C60 WH-18 H807-C84 YL-18 2 H807-AC2 YL-16
NC COM
F750-E58 YL-18 HARNESS ASSEMBLIES
NO
158-W8 BR-12 120-Y6 YL-16 BK-16 1 607-M7 PK-18 614-M3 PU-18 1 BK-16 105-C193 RD-18 124-P9 GN-14 J847-E35 GN-18 IDENT PART NO. CHG LOC DESCRIPTION NOTE
122-Y16 BU-16 H1 H1 BK-16 2 200-M8 BK-18 200-M6 BK-18 2 BK-16 200-Y14 BK-16 124-C190 GN-14 CONN 24 J848-E31 BU-18 123-E40 WH-18 A 180-8701 03 G-13 CASE
158-Y34 BR-14 200-Y49 BK-8 129-C24 BU-18 CTR BK PEDAL SW 200-E38 BK-18 C 210-4610 01 I-10,I-11 PLATFORM
159-Y35 BU-14 H9 200-Y8 BK-16 132-7077 614-E39 PU-18
W-C2 OROPS REAR FLOOD OROPS FRNT RH FLD 200-C192 BK-16 129-C206 BU-18 310-E37 PU-18 E 177-5281 01 B-5 DASH
B 9X1054
2 5
201-1423 201-1422 521-Y31 YL-18 129-C27 BU-18 F 211-2665 00 D-3 ENGINE B
4
Y-C17
1552273
G-C2
3E3382
G-C1
1552273
L J-C7
1965330
V-C1
1552272
V-C2
1552269 OROPS LIGHTING GP (ATCH) 521-C21 YL-18
607-C26 PK-18 200-X3 BK-10 C-C36 308-E24 YL-18
G 177-5280 02 B-13 LEFT WIPER ATCH
GND 1552267 H 177-5279 02 A-13 RIGHT WIPER ATCH
20 Page, Color 2,

MOTOR
1
158-W8 BR-12 200-W10 BK-14 524-Y2 BU-16 1 524-G3 BU-16 4 GN-16 H 607-J12 PK-18 1 607-V1 WH-18 1 BK-16 614-C20 PU-16 200-Y14 BK-16 306-E26 GN-18
3 2 1 200-J18 BK-18 2 200-V2 BK-18 2 BK-16 497-C207 BU-18 A OR-18 + BATTERY 105-E27 RD-18 J 177-5275 02 E-14 ROOF ATCH
° T
200-Y8 BK-16 3 200-G1 BK-16 2 BK-16 3 200-C25 BK-14 J764-C209 BR-18 B BK-18 GROUND LA 177-5277 01 C-13 HEADLINER ATCH
120-Y43 YL-16 4 120-G5 YL-16 6 GY-16 4 CONN 11 200-C192 BK-16 200-C23 BK-18 G745-C83 PK-18 C WH-18 SIGNAL
P
RELAY 1 523-Y36 BR-16 5 523-G2 BR-16 3 BR-16
B+
FRONT LH FLOOD LAMP 200-C38 BK-18 M 180-8704 01 B-11 OROPS LIGHTING ATCH
115-1615 525-Y17 GY-16 6 525-G4 GY-16 5 OR-16 201-1422
NOTE H
MA-C1
3E3382
MC-C2
1552269
200-C217 BK-18
200-C132 BK-18
CTR BRK PEDAL SNSR
160-2443
DASH MA 207-2851 00 B-10 NO ROPS REAR LTG ATCH
MC 206-3558 00 B-11 NO ROPS FRONT LTG ATCH
521-W4 YL-16 CONN 4 1 607-MC1 PK-18 1 BK-16 C-C34
MA-C2 MH-C1 MH-C2 MC-C1 1552267 MH 206-3559 00 B-10 NO ROPS MIDDLE LTG HARNESS ATCH
200-W1 BK-16 LEFT DOOR WIPER MOT0R 2 200-MA1 BK-16 200-MC2 BK-18 2 BK-16 200-Y8 BK-16
C557-W5 OR-12 NOTE K 179-4810 J-C9 V-C 1 V-C 2 CONNECT TO 3 1552272 3E3376 155-2272 3E3376 200-Y49 BK-8 497-C208 BU-18 A OR-18 + BATTERY N 180-8705 01 E-1 A/C COMPRESSOR ATCH THIS SCHEMATIC IS FOR THE D3G-D5G PHASE III
1965330 1552272 1552269 C-C8 LOC (A-12) 4 607-MA2 PK-18 607-MA4 PK-18 1 607-MH1 PK-18 1 J764-C210 BR-18 B BK-18 GROUND P 194-3836 01 D-9 HEATER ATCH 174-6035 CHG 02
W-C4 614-J13 PU-18 1 614-V3 WH-18 1 BK-16 5 614-MA3 PU-18 200-MA5 BK-18 2 200-MH2 BK-18 2 NO ROPS FRNT LH FLD 200-P13 BK-18 M730-C44 YL-18 C WH-18 SIGNAL
1779646 Y-C16 H-C1 H-C2 T 206-2477 00 F-7,G-7 STARTING/CHARGING
521-W12 YL-18 L 200-J19 BK-18 2 200-V4 BK-18 2 BK-16 6 614-MA3 PU-18 3 614-MH3 PU-18 3 201-1422 200-P15 BK-18 COMPONENTS ARE SHOWN INSTALLED ON A FULLY OPERABLE
1 C557-W5 OR-12 1552273 3E3382 1552273 3 200-MA6 BK-18 4 200-MH4 BK-18 4 200-P31 BK-14 DECEL PEDAL SNSR V 180-8707 01 B-12 E-ROPS FRONT LIGHTING (LH) ATCH
GND
MOTOR
2 200-W7 BK-14 527-Y39 GN-16 1 527-H3 GN-16 4 GN-16 MOTOR H 4 CONN 12 MC-C3 515-P2 GY-14 160-2443 SYMBOL DESCRIPTION V 180-8707 01 B-12 E-ROPS FRONT LIGHTING (RH) ATCH MACHINE WITH THE KEY AND ENGINE OFF, XMSN SHIFTER
2 1 FRONT RH FLOOD LAMP MA-C4 CONN 14 CONN 15 1552269 IN NEUTRAL,AND PARK BRAKE IN THE OFF POSITION.
VA 208-9944 00 A-11 EROPS SWEEPS LTG (INSIDE) ATCH
CONDENSER MOTOR 1
200-Y25
122-Y50
BK-16
BU-16
3
4
200-H1
122-H5
BK-16
BU-16
2
6
BK-16
GY-16
T°
EROPS LTG 201-1422
NOTE H BK-16 1
1552269
607-MA7 PK-18
614-MC3 PU-18
200-MC4 BK-18
1
2
BK-16
BK-16 403-C197 GN-18
WIRE GROUP COLOR DESCRIPTIONS BLADE, SPADE, RING, VF 208-9945 00 A-12 EROPS SWEEPS LTG (OUTSIDE) ATCH
P OR SCREW TERMINAL
180-5928
H17 526-Y37
528-Y38
YL-16
PK-16
5 526-H2
528-H4
YL-16
PK-16
3 BR-16
B+
(ATCH) BK-16 2 200-MA8 BK-18 403-C198 GN-18
403-C71 GN-18
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF. VC 208-9946 00 C-11 OROPS SWEEPS LTG NOTE A: F-3 SWITCH SHOWN AT OPERATING TEMPERATURE
6 5 OR-16 CIRCUIT CONNECTED W 185-4303 00 C-15 A/C CONDENSOR ATCH SWITCH WILL CLOSE WHEN THE TEMPERATURE
CONN 5 H1 H1 NO ROPS REAR FLOOD
NO ROPS FRNT RH FLD 517-P4 BU-14 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON. X 185-4305 00 D-9 HVAC BOX ATCH IS LESS THAN 45 DEGREES F
521-W3 YL-16 201-1423
201-1422 521-Y31 YL-18
200-W2 BK-16 200-Y8 BK-16 521-C21 YL-18 CIRCUIT NOT CONNECTED Y 200-7848 01 D-15 EROPS ATCH NOTE C: F-11,F-7,F-3 ASSEMBLE TERMINALS TO STUD
W-C3 STARTING CIRCUIT.
9X1054 2 5
105-Y10 RD-18
200-Y15 BK-14 RIGHT DOOR WIPER MOTOR NO ROPS LIGHTING GP (ATCH) 607-C26 PK-18
C-C32A C-C32
GAUGE CIRCUIT.
ELECTRICAL CONNECTION
AC
FA
177-5289
207-2858
00
01
B-7
G-1
CENTER BRAKE PEDAL ASSEMBLY
HOOD
NOTE E: E-1 NORMALLY OPEN BEFORE REFRIGERANT CHARGE
4 200-Y3 BK-14 179-4811 3E3370 1552267 129-C27 BU-18 + TO MACHINE STRUCTURE SYMBOLS
159-W9 BU-12 A 124-C190 GN-14 200-C23 BK-18 - WIRE ASSEMBLIES NOTE F: E-8,E-9,A-7 THE FOLLOWING WIRES ARE TO BE TWISTED
1
200-Y4 BK-14 CONN 18 B 522-C191 WH-18
GROUND CIRCUIT. INTERNAL ELECTRICAL ABBREV COLOR CP 195-8730 00 G-8 CODE PLUG WIRE AS. I-12,G-9 TOGETHER AT LEAST ONE TURN PER 25 mm
3
200-Y13 BK-18 200-Y49 BK-8 200-Y49 BK-8 C 614-C195 PU-18 CONNECTION TO SURFACE RD RED HF 203-3986 00 F-15 HYDRAULIC FILTER WIRE AS. 944-OR AND 945-BR
200-Y8 BK-16 VA-C1 VF-C2 POWER PORT
STARTING AID CIRCUIT. OF COMPONENT
1552272 1552269
WH WHITE TA 213-6309 00 F-11 ALT BRKR/MAIN BRKR WIRE AS.
RELAY 2 200-Y25 BK-16 200-Y14 BK-16 WHEN HVAC ATTACHMENT IS USED 105-C205 RD-18 178-7539
VITAL INFORMATION MANAGEMENT. OR ORANGE NOTE G: G-3 FOR JAPANESE FUEL PRIMING PUMP
CONNECTOR CABLE ASSEMBLIES
A 115-1615
C556-W6 BU-12 200-Y47 BK-18 200-Y14 BK-16
521-Y31 YL-18 1
2
607-VA1 PK-18
200-VA2 BK-18 VA-C2 VF-C1
607-VF1 PK-18
200-VF6 BK-18
1
2
BK-16
BK-16
REMOVE C-C32A CAP CONNECTOR
AND CONNECT C-C32 TO P-C1
129-C27 BU-18
200-C23 BK-18
YL YELLOW
AA 180-8709 02 D-11 BATTERY + TO PWR STUD NOTE H: B-12 EROPS LIGHTING HARNESS IS OMITTED WHEN MACHINE IS A
200-Y48 BK-18
Y-C3 C-C8A C-C8 CONN J-C7 3 1965330 1552272 945-C202 BR-18 C-C33 C-C33A PANEL LAMP CIRCUIT. ATCH WIRE, CABLE, PK PINK EQUIPPED WITH SWEEPS ATTACHMENT
W-C5 3E3382 3E3382 1552273 LOC (B-12) P-C1 1552273 BK BLACK CC 180-8711 01 E-11 DISCONNECT SW TO FRAME GND
200-Y46 BK-18 4 607-VA1 PK-18 1 607-VF1 PK-18 944-C201 OR-18 3E-3381 COMPONENT
1779646 200-Y52 BK-18 105-Y10 RD-18 1 1 105-C193 RD-18 H9 200-VA6 BK-18 2 200-VF2 BK-18 FRNT LH FLD 3E3370 403-C198 GN-18 105-C205 RD-18 1 WIPER/WASHER CIRCUIT. GY GRAY EE 180-8710 01 E-11 DISCONNECT SW TO BATTERY NOTE J: C-5 THIS A SIMPLIFIED SCHEMATIC SYMBOL FOR GENERAL
1 C556-W6 BU-12 200-Y52 BK-18 2 2 200-C192 BK-16 614-VA3 PU-18 3 614-VF3 PU-18 201-1422 124-P9 GN-14 A 202-C203 BK-18 202-C203 BK-18 2 CIRCUIT GROUPING PU PURPLE FF 180-8713 03 E-11 HEAVY DUTY BATTERY + ATCH REFERENCE OF PART FUNCTIONALITY
MOTOR VA-C3 HEATER AND AIR CONDITIONER CIRCUIT. H#
2 200-W11 BK-14 521-Y31 YL-18 521-Y42 YL-18 3 3 521-C21 YL-18 200-VA8 BK-18 4 200-VF4 BK-18 522-P5 WH-18 B 129-C206 BU-18 129-C206 BU-18 3 PRODUCT LINK DESIGNATION BR BROWN GG 180-8717 01 D-4 STARTER TO FRAME GND
521-Y5 YL-18 521-Y42 YL-18 607-Y27 PK-18 4 4 607-C26 PK-18 1552272 VF-C3 614-P36 PU-18 C 944-C201 OR-18 4 NOTE K: B-14 LH AND RH HARNESSES REQUIRE INSERTION OF SOCKETS INTO
CONN 16 1552269 POWERTRAIN CONTROL CIRCUIT. GN GREEN HH 180-8714 01 E-11 HEAVY DUTY BATTERY - ATCH
CONDENSER MOTOR 2
614-Y1 PU-16 5 5 614-C20 PU-16 1 614-VA3 PU-18 945-C202 BR-18 5 SPLICE BU BLUE 155-2273 CONNECTORS PER SCHEMATIC AFTER ASSEMBLY INTO
180-5928 607-Y41 PK-18 6 6
CONN J-C9
2 200-VA4 BK-18 614-VF3 PU-18 1 BK-16 403-C198 GN-18 6 KK 187-4489 01 E-7,D-11 CASE GND TO PLATFORM GND DOORS.
CONN 13 LOC (B-12)
3 200-VF8 BK-18 2 BK-16 614-C20 PU-16 614-C194 PU-18 DATA LINK CIRCUIT.
607-Y44 PK-18 607-Y27 PK-18 4 614-C216 PU-18
CONDENSER GP (ATCH) 614-Y1 PU-16
WHEN EROPS ATTACHMENT IS USED
REMOVE C-C8A CAP CONNECTOR FRNT RH FLD
614-C195 PU-18 NOTE F CONN 25

180-5927 AND CONNECT C-C8 TO Y-C3 201-1422 614-P36 PU-18 614-P14 PU-18
EROPS SWEEPS LIGHTING (ATCH) 614-P12 PU-18 RIGHT HAND CONSOLE
EROPS (ATCH) C546-P6 WH-18

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1