A.B Dick 3500 Manual PDF

®
3500
Parts Catalog
© 1996, A.B.Dick Company P/N 177196 (REV.O)

WARNING:
THIS PARTS MANUAL IS INTENDED ONLY TO ASSIST QUALIFIED PERSONS IN

IDENTIFYING SPECIFIC REPAIR PARTS. THIS PARTS MANUAL IS NOT A SERVICE
REPAIR MANUAL NOR IS IT A SUBSTITUTE FOR A SERVICE REPAIR MANUAL.
UNQUALIFIED PERSONS SHOULD NOT ATTEMPT TO SERVICE THE EQUIPMENT
DESCRIBED IN THIS PARTS MANUAL, WHETHER BY IMPROPER USE OF THIS
PARTS MANUAL OR OTHERWISE. ANY UNQUALIFIED PERSON ATTEMPTING TO
SERVICE SUCH EQUIPMENT MAY INADVERTENTLY CAUSE DAMAGE TO THE
EQUIPMENTAND/ORCAUSEINJURYTOHIMSELFORTOOTHERS. USERSOFTHIS
PARTS MANUAL ARE ADVISED THAT A.B.DICK COMPANY WILL NOT BE LIABLE
FOR ANY PERSONAL INJURY OR PROPERTY DAMAGE ARISING OUT OF ANY USE
OF THIS PARTS MANUAL FOR PURPOSES FOR WHICH IT WAS NOT INTENDED.
IMPORTANT NOTICE:
The information contained in this publication is proprietary to A.B.Dick Company. No part of this
document may be reproduced, stored in a retrieval system, or transmitted, in any form or by any
means, electronic, mechanical, photocopying, recording, or otherwise, without the prior written
permission of A. B. Dick Company. Further, the custodian of this document shall ensure that no part
of this document shall be used for any purpose other than that for which it is intended without the
prior written permission of A.B.Dick Company.
Parts Catalog
GENERAL INFORMATION
PARTS IDENTIFICATION AND ORDERING INSTRUCTIONS
I. Order Repair Parts by part number only. Do not order by figure and index numbers.
II. In some instances you will see two or more of the same index number with different
part numbers. In such cases, please read the full description for your particular needs.
Ill. The following symbols and abbreviations are used consistently as aids in identification:
A. Symbols
1. (*) Part of an assembly and not sold separately.
2. (**) Identifies the part as having no part number.
3. (***) Are used for all other pertinent remarks.
B. Abbreviations
1. OS = Operator Side
2. NOS = Non-operator Side
3. I.D. = Inside Diameter
4. O.D. = Outside Diameter
5. O.A.L. = Overall Length
6. V. =Volts
7. Hz. =Cycles Per Second
8. Amp. = Amperes
9. Dia. = Diameter
10. HP. = Horsepower
11. AIR = As Required
Parts Catalog
Contents
COVERS AND GUARDS ................................................................................................. 1-1
INK AND DAMPENER SAFETY GUARDS ...................................................................................... 1-3
IMPRESSIONSAFETYGUARD ...................................................................................................... 1-5
OPERATOR SIDE COVERS - PART 1 .......................................................................................... 1-7
OPERATOR SIDE COVERS- PART 2 .......................................................................................... 1-9
NON-OPERATOR SIDE COVERS- PART 1 ............................................................................... 1-11
NON-OPERATOR SIDE COVERS- PART 2 ............................................................................... 1-13
CHAIN DELIVERY I FEED END SAFETY GUARDS ..................................................................... 1-15
CRANKS, HANDLES AND KNOBS ................................................................................ 2-1

CRANKS, HANDLES AND KNOBS ................................................................................................ 2-3
TOWERS .......................................................................................................................... 3-1

ROLLER CONFIGURATION ........................................................................................................... 3-3
DAMPENER TROUGH AND BRACKETS ....................................................................................... 3-5
DAMPENER PAN ROLLER ASSEMBLY ........................................................................................ 3-7
DAMPENER METERING AND OSCILLATOR RIDER ROLLER .................................................... 3-9
DAMPENER FORM SOCKET ASSEMBLY (OS)- PART 1 .......................................................... 3-13
DAMPENER FORM SOCKET ASSEMBLY (NOS)- PART 1 ....................................................... 3-15
DAMPENER FORM SOCKET ASSEMBLY (OS)- PART 2 .......................................................... 3-17
DAMPENER FORM SOCKET ASSEMBLY (NOS)- PART 2 ....................................................... 3-19
DAMPENER METERING ROLLER SOCKET (OS) ...................................................................... 3-21
DAMPENER METERING ROLLER SOCKET (NOS) ................................................................... 3-23
DAMPENER MOTOR ASSEMBLY ................................................................................................ 3-25
DAMPENER AIR CYLIN DER & SHAFT ASSEMBLY .................................. ................................... 3-27
OSCILLATOR LEVER SYSTEM ................................................................................................... 3-29
OSCILLATOR ROLLER ASSEMBLIES ........................................................................................ 3-31
INK FOUNTAIN ASSEMBLY- PART 1 .......................................................................................... 3-33
INKFOUNTAINASSEMBLY-PART2 .......................................................................................... 3-35
INK FOUNTAIN ROLLER DRIVE SYSTEM .......................... ......................................................... 3-37
INK RATCHET HANDLE STOPS .................................................................................................. 3-39
INK FOUNTAIN SWEEP ASSEMBLY ........................................................................................... 3-41
INK DUCTOR ASSEMBLY ......................................................................... ................................... 3-43
INK METERING AND UPPER INK TRANSFER ROLLER ............................................................ 3-45
LOWER INK TRANSFER ROLLER .............................................................................................. 3-47
JUMBO INK TRANSFER ROLLER ............................................................................................... 3-49
INK DISTRIBUTOR ROLLERS ..................................................................................................... 3-51
INK FORM SOCKET #1 (OS) .............................................. ......................................................... 3-55
INK FORM SOCKET # 1 (NOS) .................................................................................................... 3-57
INK FORM SOCKET #2 (OS) ....................................................................................................... 3-59
INK FORM SOCKET #2 (NOS) .................................................................................................... 3-61
II
Parts Catalog
INK FORM SOCKET #3 (OS) ................................................................ ........................................ 3-63

INK FORM SOCKET #3 (NOS) ................................................................................... .................. 3-65
DISTRIBUTOR I TRANSFER BRACKETS & INK FORM SOCKET ASSEMBLIES (OS) ................. 3-67
DISTRIBUTOR I TRANSFER BRACKETS & INK FORM SOCKET ASSEMBLIES (NOS) ............... 3-69
IDLER GEAR AND OSCILLATOR BUSHINGS .............................................................................. 3-71
INK DUCTOR SOLENOID AND LATCH ASSEMBLY (NOS) ........................................................ 3-73
CAM SHAFT ASSEMBLY ............................................... ................................................................ 3-75
THROW-OFF CAM ASSEMBLY ... ................................................................................................ 3-77
IDLER GEAR ASSEMBLY (OS) ..................................................................................................... 3-79
MAIN IDLER GEAR ASSEMBLY ..................................................................................................... 3-81
TOWER FRAME BUSHINGS AND BRACES ................................................................................ 3-83
ATTACHING THE BASE, MID AND TOWERS ............... ................................................................ 3-85
CLEAN-UP TROUGH ..................................................................................................................... 3-87
OIL SYSTEM ..................................................................................................................... 4-1

BASE ELECTRICAL ........................................................................................................................ 4-3
LUBRICATION SYSTEM (OS) ......................................................................................................... 4-5
LUBR ICATION SYSTEM (NOS) .......................................................... "........................................... 4 -7
MID SECTION ................................................................................................................... 5-1

ANTI-SCUFF UNIT ........................ .................................................................................................. 5-3
PLATE AND PAPER ADJUSTMENT- PART 1 .............. .............................................. .................... 5-5
PLATE AND PAPER ADJUSTMENT- PART 2 ................................................................................ 5-7
PLATE AND PAPER ADJUSTMENT- PART 3 ...................................... .......................................... 5-9
PLATE AND PAPER ADJUSTMENT- PART 4 .............................................................................. 5-11
PLATE AND PAPER ADJUSTMENT- PART 5 .............................................................................. 5-13
PLATE AND PAPER ADJUSTMENT- PART 6 ...................................... ........................................ 5- 15
PLATE AND PAPER ADJUSTMENT- PART 7 ...................................... ........................................ 5-17
PULL GUIDE SPROCKET DRIVE ASSEMBLY ..................................... ........................................ 5-19
PULLGUIDEANDVACUUMASSEMBLY ..................................................................................... 5-21
PNEUMATICS- OPE RATOR SIDE- PART 1 .............................................................................. 5-23
PNEUMATICS- OPE RATOR SIDE- PART 2 .............................................................................. 5-25
PNEUMATICS- NON-OPERATOR SIDE ...................................................................................... 5-27
LINKAGE- NON-OPERATOR SIDE .............................................................................................. 5-29
PULL GUIDEASSEMBLY .............................................................................................................. 5-31
UPPER FORWARDING ROLLER ASSEMBLY ..................................... ........................................ 5-33
MASTERCYLINDER .................... ....................................................... ......................................... 5-35
PLATECLAMPASS EMBLY ................................................................... ........................................ 5-37
BLANKET CYLINDER ................................................................................................................... 5-39
IMPRESSION CYLINDER ............................................................................................................. 5 -41
TRANSFER CYLINDER- PART 1 ................................................................................................ 5-43
TRANSFER CYLINDER- PART 2 ................................................................................................ 5-45
TRANSFER GRIPPER BAR ASSEMBLY ..................................................................................... 5-47
Ill
Parts Catalog
STOP FINGER ASSEMBLY AND GUIDE ..................................................................................... 5-49

TIE BARS ...................................................................................................................................... 5-51
ATIACHING THE BASE, MID, AND TOWERS .......................................... ................................... 5-53
DRIP PANS .................. ................................................................................................................. 5-55
UNIVERSAL FEEDER ..................................................................................................... 6-1

FEEDER SIDE GUIDE SPROCKETS ................................. ........................................................... 6-3
PAPER GUIDE RAILS ..................................................................................................................... 6-5
PAPER GUIDE RAIL CRANKS ....................................................................................................... 6-7
CAM ASSEMBLY AND EMERGENCY STOP SWITCH .................................................................. 6-9
DOUBLES DIVERT ASSEMBLY ................................................................................................... 6-11
AIRANDVACUUMCONTROLVALVES ................... ................................. ................................... 6-13
HEADER TUBE ASSEMBLY .............. ........................................................ ................................... 6-15
PULLOUT ROLLERS ................................................................................................................... 6-17
VACUUM TIMING SPROCKET ..................................................................................................... 6-19
SPROCKET ASSEMBLY- PART 1 .............................................................................................. 6-21
SPROCKET ASSEMBLY- PART 2 .............................................................................................. 6-23
PAPER FIE ED GUIDES ................................................................................................................. 6-25
HOLD DOWN STRAPS ................................................................................................................ 6-27
FEED LIN K ASSEMBLY ...................................... .......................................................................... 6-29
FEED SOLENOID .................................................................................................. ....................... 6-31
FEEDER DRIVE ............................................................. ........................... ................................... 6-33
FEEDER CONVEYOR ASSEMBLY- PART 1 .............................................................................. 6-35
FEEDER CONVEYOR ASSEMBLY- PART 2 .............................................................................. 6-37
BAIL BAR ASSEMBLY .. ................................................................................................................. 6-39
BRUSHASSEMBLIES ....................... ........................................................................................... 6-41
LOWER FEED ROLLER AND GEAR ASSEMBLY ...................................................................... 6-43
CONVEYOR HOLD DOWN ROLLER .......................................................................................... 6-45
SHEET SEPARATOR AND BLOWER ..................................................... .................................... 6-47
BAIL BAR SOLENOID I LEVER ASSEMBLY ................................................................................ 6-49
DOUBLES SENSOR .................................................................................................................... 6-51
FEED TABLE ASSEMBLY ............................................................................................................ 6-53
STREAM FEEDER ........................................................................................................... 7-1

STREAM FEEDER COVERS ......................................................................................................... 7-3
SHEET SEPARATION UNIT - PART 1 ............................................................................................ 7-5
SHEET SEPARATION UNIT - PART 2 ............................................................................................ 7-7
SHEET SEPARATION UNIT- PART 3 ................................. ........................................................... 7-9
SHEET SEPARATION UNIT- PART 4 .......................................................................................... 7-11
SHEET SEPARATION UNIT - PART 5 ................................. ......................................................... 7-13
SHEET SEPARATION UNIT - PART 6 .......................................................................................... 7-15
SHEET SEPARATION UNIT- PART 7 .......................................................................................... 7-17
SHEET SEPARATION UNIT- PART 8 .................................................... ...................................... 7-19
IV
Parts Catalog
SHEET SEPARATION UNIT- PART 9 ........................................................................................... 7-21

SHEET SEPARATION UNIT- PART 10 ......................................................................................... 7-23
SHEET SEPARATION UNIT MOUNTING ....................................................................................... 7-25
STREAM FEEDER AIR HOSE ASSEMBLY ................................................................................... 7-27
ASSEMBLIES ON FRAME (NOS) .................................................................................................. 7-29
CONTROL BRACKET ASSEMBLY .............................................................................................. 7-31
STREAM FEEDER CONVEYOR BELT TENSION HARDWARE ................................................. 7-33
DRIP PAN AND COINVEYOR AREA .............................................................................................. 7-35
STREAM FEEDER CONVEYOR ASSEMBLY ............................................................................... 7-37
STREAM FEEDER SHEET GATE ASSEMBLY ............................................................................ 7-39
IN FEED AND SHEET GATE CAM ASSEMBLY .............................................................................. 7-41
CROSSBAR ASSEMBLY ............................................................................................................... 7-43
STREAM FEEDER FEEDING HARDWARE .................................................................................. 7-45
DOUBLES SENSOR ASSEMBLY ................................................................................................. 7-47
DRIVE SHAFT AND INFEED ROLLER ......................................................................................... 7-49
DOLLY ELEVATOR ....................................................................................................................... 7-51
DOLLY ASSEMBLY ....................................................................................................................... 7-53
STREAM FEEDER FRAME (OS) .................................................................................................. 7-55
STREAM FEEDER FRAME (NOS) ................................................................................................ 7-57
STREAM FEEDER UPPER TIE BAR ASSEMBLY ........................................................................ 7-59
STREAM FEEDER BASE- PART 1 .............................................................................................. 7-61
STREAM FEEDER BASE- PART 2 ............................................................................................. 7-63
STREAM FEEDER PUMP, COMPRESSOR & BASE ASSEMBLY .............................................. 7-69
CHAIN DELIVERY ............................................................................................................ 8-1

SUPER BLUE ........ ........................................................ .................................................................. 8-3
GRIPPER BAR ................................................................................................................................. 8-5
POWDER SPRAY- WIRING AND BAFFLE ASSEMBLY ................................................................ 8-7
COVER ASS EM BLY ........................................................................................................................ 8-9
SPRAYEA ASSEMBLY .................................................................................................................. 8-11
LAMP HOUSING ............................................................................................................................. 8-13
FINALASSEMBLY ......................................................................................................................... 8-15
POWDER SPRAY ASSEMBLY ..................................................................................................... 8-17
INFRARED I POWDER SPRAY ASSEMBLY- PART 1 ................................................................ 8-19
POWDER SPRAY COMPRESSOR ASSEMBLY .......................................................................... 8-25
TABLE DESCENT ......................................................................................................................... 8-27
PAPER SUPPORT TAB AND FRONT GUARD ............................................................................. 8-29
TRACKASSEMBLY ....................................................................................................................... 8-31
CHAIN DELIVERY (NOS FRAME) - PART 1 .................................................................................. 8-33
v
Parts Catalog
CHAIN DELIVERY (NOS FRAME)- PART 2 ................................................................................. 8-35

CHAIN DELIVERY (OS !F RAME)- PART 1 ................................................................................... 8-37
CHAIN DELIVERY (OS FRAME)- PART 2 ................................................................................... 8-39
CHAIN DELIVERY JOGGER ASSEMBLY ..................................................................................... 8-41
FRONT JOGGER ......................................................................................................................... 8-43
SPROCKET SHAFT ASSEMBLY ................................................................................................. 8-45
BACK STOP ADJUSTING SHAFT ................................................................................................ 8-47
JOGGER MECHANISM ................................................................................................................. 8-49
WORK LIGHT RETROFIT KIT ...................................................................................................... 8-51
CHAIN DELIVERY RATCHET AND WORM GEAR ....................................................................... 8-53
CHAIN DELIVERY SPROCKET ASSEMBLY ................................................................................ 8-55
BACK STOP ASSEMBLY ............................................................................................................. 8-57
BASE ................................................................................................................................ 9-1

FEED TABLE MOTOR AND POSITION CONTROL ASSEMBLY ............. ..................................... 9-3
HEATEXCHANGERASSEMBLY .................................................................................................... 9-5
TUBINGSCHEMATIC ..................................................................................................................... 9-7
UNIVERSAL FEEDER PUMP, COMPRESSOR & BASE ASSEMBLY ........................................... 9-9
PNEUMATIC AIR COMPRESSOR ................................................................................................ 9-1 1
BASE ASSEMBLY- PART 1 ...................................................................... ................................... 9-13
BASEASSEMBLY-PART2 ......................................................................................................... 9-15
TANK AND MANIFOLD ASSEMBLY .............................................................................................. 9-17
DRIVE MOTOR ............................................................................................................................. 9-19
ELECTRICAL ................................................................................................................. 10-1

MAIN POWER TRANSFORMER .................................................................................................. 10-3
ELECTRONICS BAY ASSEMBLY- PART 1 ................................................................................. 10-5
ELECTRONICS BAY ASSEMBLY - PART 2 ................................................................................. 10-7
ELECTRONICS BAY ASSEMBLY - PART 3 ................................................................................. 10-9
DRIVE MOTOR INVERT ER ASSEMBLY- PART 1 .................................................................... 10-11
DRIVE MOTOR INVERT ER ASSEMBLY- PART 2 .................................................................... 10-13
DRIVE MOTOR INVERT ER ASSEMBLY - PART 3 .................................................................... 10-15
BRIDGE CAPACITOR ASSEMBLY ............................................................................................. 10-17
DISTRIBUTION CAB INET PC BOARD ASSEMBLIES ................................................................ 10-19
DISTRIBUTION CABINET ASSEMBLY ....................................................................................... 10-21
POWDER SPRAY CONTROL PANEL ....................................................................................... 10-23
CONTROL PANEL- PART 1 ...................................................................................................... 10-25
INTER-TOWER AND FEEDER CONTROL PANELS ................................................................ 10-33
BALLASTTRANSFORMERASSEMBLY .................................................................................... 10-35
DRIVE MOTOR AND CABLE .............................................................................. ........................ 10-37
VI
Parts Catalog
D.C. POWER CABLE ASSEMBLY- (NOS) . ................. .............................................................. 10-39

PNEUMATICCOMPRESSORASSEMBLY ................................................................................. 10-41
MOTOR DRIVE HARNESS- PART 1 .......................................................................................... 10-43
MOTOR DRIVE HARNESS - PART 2 .......................................................................................... 10-45
AIR SOLENOID HARNESS (NOS) .............................................................................................. 10-47
AIR I VACUUM POWER CORD ................................................................................................... 10-49
FEEDER HARNESS (OS) ........................................................................................................... 10-51
AC DEVICE CONTROL HARNESS ............................................................................................. 10-53
AIR SOLENOID HARNESS (OS) .. ............................................................................................... 10-55
ACCESSORY POWER HARNESS ............................................................................................. 10-57
INTER-TOWER HARNESS ......................................................................................................... 10-59
SENSORS .................................................................................................................................. 10-61
HARNESS- GUARD SWITCHES (OS) ....................................................................................... 10-63
HARNESS- GUARD SWITCHES (NOS) .................................................................................... 10-65
3500 POWDER SPRAY CHAIN DELIVERY HARNESS .............................................................. 10-67
VDE LINE FILTER ASSEMBLY .................................................................................................... 10-69
FEEDER WIRING I POWER SWITCH ........................................................................................ 10-71
INDEX ................................................................................................................................ 1-1
VII
COVERS AND GUARDS
COVERS AND GUARDS
Century 3500 Parts Catalog 1-1

COVERS AND GUARDS
,.--------2
1 --~
~---5
7
3
4 6
1 8
16 10
11
15 5
14
16
7
18
6
13 8
7
12
'--------22
1-2 Century 3500 Parts Catalog

COVERS AND GUARDS
INK AND DAMPENER SAFETY GUARDS
Index Part
No. No. Descript ion Quant ity
1 186900 GUARD - Ink ..................... ..... ........... .......... .... .......................... ....................................................... 1
2 186924 SCREW · Guard Pivot Stud .................................. ............................ ................ .............................. 3
3 186914 SHAFT· Cam Assem.bly, Left Pivot ..................................................... ................................ ............ 1
4 186915 SHAFT· Cam Assembly, Right Pivot ..... ......... .............................. ................................................... 1
5 187157 STRUT ASSEMBLY - N.O.S ............ ......... ...... ........... ..... ................................................................. 2
6 180589 TUBE -CONNECTOR .......................... .......... ... ... ......... ..... .......... .............................. ..................... 4
7 001681 SCREW- 6-32 X 1/4' . ............................. ............... ..... .......... ........................................................... . 4
8 180588 TUBE - Release .............................................. ........... ..... ...... ......... ..... ............................................. 2
9 186901 GUARD - Dampener, Tower2 ................ .......... .. ... .............. ..... .......... .............................................. 1
10 186933 HAN DLE -DampenerGuard .............. .................... ......................... ................................................. . 4
11 100625 SCREW - 1/4-20 X 1/2" .... ................ .... ..... ........ ........ ..... ............... .................. ................................ 8
12 100871 NUT · 1/4 -20 ...... ................. .............. .......... ..... .................... .......... ..................... .............. ............... 8
13 187155 STRUT ASSEMBLY - O.S.................... ............................................................. .............................. 2
14 102301 SCREW - 6-32 X 7/8" ....... ................. .............. ...... ..... ...... .... ......... ..... .............................................. 1
15 101979 SCREW • 6·32 X 1·5/8 " ..... ····· ......................... .. ... ..... ..... .... ······ .... ..... ...... ..... .... ............... .... ........... . 2
16 253822 SWITCH ............. ....... ......... .... .......... ..... ......... ................ ................... .................... .......................... 2
17 180177 SPACER ............ ............... ................ .............. ........... ....................................................... .............. . 1
18 186920 BRACKET - TOWER SWITCHES ................ .......... ................................................... ....................... 1
19 190731 PLATE & NUT · 6·32 ............................. .... ..... ................................................................................ . 1
20 014812 NUT - 6-32 ........... .................... ................................... ...................................................................... 1
21 186902 GUARD - Dampener, Tower 1 ........... ..... ...... .... .. ... .......... .... .......... .................... ........ .. ..... ................ 1
22 174206 GUARD· Pull Guide ......................... ................ ...... .... ................ .............. ................. ... .................... 1

COVERS AND GUARDS
.....------ 3
13
11 - - - I
15 - -
'
L___ _ _ 7
14
12 '------ 4

COVERS AND GUARDS
IMPRESSION SAFETY GUARD
Index Part
No. No. Description Quantity
1 186928 BRACKET - Latch Support ............... .... .......... ..... ......................... ............... .............. ..................... 2
2 101626 SCREW - 1/4-28 X 5/8" ..... ........................................ ................... ...... .............. ............................... 4
3 186925 SHAFT & LATCH ASSEMBLY ........... ..... ..... ..... ............................................................................... 1
4 186942 BUMPER - Guards .. ......... ..... ................ ..... ............................................................... ..................... 2
5 186910 GUARD - Tower 1 .... ......................... ........................ ..... ..... ............... ............................................. 1
6 102301 SCREW- Hex, 6-32 x 7/8" .................... ......... ...... .......... .............. ................................................... 4
7 014812 NUT - 6-32 .......... ................................................. ..... ...................................................................... 4
8 186921 BRACKET- Switch .......................... ......... ................ ..... ..... ............... .............................. ............... 2
9 233822 SWITCH ................................. ............... ............... ..... ..... ...... ......... .................................................. 2
10 186916 SHAFT - Cam Assembly (Impression Cylinder Guard) ................................ ................ ................ 2
11 186903 GUARD - Impression Cylinder ........ ............... .......... .... .............. .. ................................................. 1
12 186904 GUARD· Scuff Segment .............................................. ..... ........... .......................... ........................ 1
13 001568 SCREW - Phillips, 6-32 x 3/8" ...................................................... ........................ .. ........ ................ 2
14 100716 NUT - Locking, 6-32 ......... .............................. .......... ..... ............... ............... .... .......... ..................... 2

COVERS AND GUARDS

COVERS AND GUARDS
OPERATOR SIDE COVERS- PART 1
Index Part
1 102165 SCREW · Phillips, 10-12 x 1-1/4" ...... .............. ................................................................................. 8

2 101144 NUT- Self Clinching ........... .................... ..... .......... ................ ..... .... ..... ............... .................. ............ 8
3 014295 SCREW - Phillips, 6-32 x 3/8" .......... ............. ........................................................... ....................... 8
4 173127 NUT - Self Clinching ............... ................ ..... ..... ............................................. ................................... 8
5 001649 SCREW - Phillips, 10-32 x 1/2" ................. ............... ..... ...... .... .................... ..... ....... ....................... 6
6 172908 BEZEL - Plastic Frame ...... .............. ..................... ........... ................................................................ 4
7 186825 INSERTS- Cover, Tower 1 and 2 ........................... ..... .......... ............................................................ 2
8 101743 SCREW - Phillips, Tower Insert ........ ........... .............. ...... ..... ........................ ............. .. ..................... 8
9 174207 COVER - Feeder ....... o o . . o o o o o o o o o oo o o o o o oo O o o o o o o o o o o o oo oo . . .oo . 1
. . . . . . . . . . . oo oo oo oo o o o o . . . . . . . . . . o o . . . . . . . oo . . o o o o o o o o o o o o oo oo o o o o o o o o . . . . .
10 173043 COVER -Feeder, Mid ...... .... 1

o o . . o o o o o o o o o o o o o o oo o o o o o o o o · · o o o o . . . . . . . . . . . . . . o o . . . . . . . . . . . . o o . . o o . . . . . . . . . . . . . . . . . . o o . . . . . . . . o o . . . . . . . . . .
11 186492 COVER - Tower 1 ...... ........ .......................... .... ........... ...... .... ...... 1 oo . .... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .oo . . . . . . . . .
12 186495 COVER · Mid ..... ....... oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . .. . . . . . . . . . . . . 1

.. .. .. ....... . ..... . .......... .. .. .. .. . ... .. .. .... .. .. ..... .. ....
13 186494 COVER - Tower2 ...... ............. ......................... ...... ............................................................ .... 1 00 . . 00 . . . . .
14 186496 COVER- Filler Delivery .... ................ ..... ............ ... ............................. ........... ............ .. .................... . 1
15 174188 DECAL · Pull Guide Vacuum ................. ..... .... ...................... ..... .... ......... ...... ................... ............... . 1
16 187084 DECAL -Ink Control .. ...................................................... ................ .... ................ ............................. 2
17 102157 SCREW- Button, 10-32 x 1/2" .............. .... ........... ...... .......... .............................. ......... ...... ............... 2
18 174194 DECAL - Back Jogger Adjustment .... .... 1
o o . . . . . . . . . . . . . o o . . . . . . . . . . . . . . . . . . . . 00 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0 0 . . . . . . . . .
19 174197 DECAL- Fountain Sweep ................................................................................................................ 2

20 174196 DECAL • Quick Raise .. 1
0 0 . . . . 0 0 0 0 0 0 0 0 . . . . . . . . . . 0 0 . . . . 0 0 0 0 . . . .. . . . . . . . 0 0 0 0 . . . . . . . . . . . . 00 . . . . 0 0 0 0 . . 0 0 0 0 . . 0 0 . . . . o o . . o o . . . . . . . . . . . . 0 0 0 0 0 0 0 0 0 0 0 0
21 174199 DECAL - Lateral Paper Adjustment .. oo . . . . . . . . 000000 . . 1

. . . . . . . . . . . . 0 0 . . 0 0 . . . . 0 0 0 0 . . . . . . . . . . o o . . . . . . . . . . . . o o . . . . o o . . . . . . . . 0 0 0 0 0 0 00 . . .
22 400757 DECAL- A.B. DICK ...... o o . . oo . . . . . . . . . . . . oo . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . 1

. . . . . . . . . . . . . . . . oo . . . . . . . . . 00 . . . . . . . . . . . . . . . . . . . . . . . . .oo . . .oo . . . .
23 174193 DECAL- Lateral Adjustment ....... 2

0 0 0 0 0 . . . . . . . . . . . oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. .. .............. . . . . 0 0 0 0 . .. .

COVERS AND GUARDS
17
(!//'"
'-24

COVERS AND GUARDS
OPERATOR SIDE COVERS - PART 2
Index Part
No. No. Description Quant ity
1 173082 NUT · Self Clinching ....................... ................................................................................................ 7

2 173081 BRACKET- Lower Cover Mount .................................................................................................... 7
3 001575 SCREW - Phillips, 10-32 x 5/16" ..... .... .............................................. .... .................. ...................... 14
4 014183 SCREW- Hex Head, 5/16-18 x 5/8" ......................................................................... ....................... 2
5 173061 RAIL- Upper Cover .................................... ............... ..... ................................................................. 1
6 173069 COVER - Lower Feeder ..................................... ................ .... .......................... .............................. 1
7 173071 COVER - Lower Delivery .................................................... ......................... .................................. . 1
8 102165 SCREW- Phillips, 10-12 x 1-1/4" ............... ..... ................... ..................................... .. ..................... 7
9 193338 WASHER- .257" I. D. x .120" thick .................................. ..... ..... ................................ .. ..................... 2
10 001667 SCREW- Hexagon, 1/4-20 x 5/8"................................... ..... ..... .... ................ ................................... 5
11 021013 SCREW- Hexagon, 1/4-28 x 5/8"......... .......................... .............. ............................ ....................... 1
12 174185 DECAL- Fork Entry ......................................... .......................... ............................... ....................... 2
13 173083 GASKET· Foam Rail ....................... ............... .... ..................... ..... .............. ................................... 2
14 173073 LOWER RAIL ................................................. ................................................................................. 1
15 173079 BRACKET- Mounting (Skirt Delivery) ... ...... ..... ......... .... ...... ..... ..... .................... ....... ....................... 1
16 173150 INSULATOR- Foam Delivery Cushion ................................................................... ....................... 1
17 172941 LABEL- Lower Feeder ................................................................................................................... 1
18 186875 LABEL - Lower Delivery (Century) .. ..... .................................................................... ....................... 1
19 186883 LABEL- Lower Delivery (Ruby) ....... ..... ............. ...................................................... ....................... 1
20 014209 SCREW · Hex Head, 5/16·24 x 5/8" ..... .................... ...... .... ..... ......................... ........ .. .................... . 2
21 173075 PANEL- Inside Delivery ................................. ........... ..... .... ..... ......................... ........ .. ..................... 1
22 150083 NUT - Lock, 10-32 .......................................................... .... ..................... .............. ... ....................... 4
23 102157 SCREW- Button Head, 10-32 x 3/8" .............. .. ... ..... .... .......... ...... .............................. ................... . 4
24 014353 SCREW· Hex Head, 1/4-28 x 1/2" ................... ........ ..... ..... .... .......... ............... ........ .. ..................... 1
25 001812 NUT- Hex ........... ............... ........... .... .... ..................... .......... ...... ..... .... ................ .... ......................... 2
26 102124 SCREW- Void, Cap Button Head ... ............... .. ... ..... ..... ...... ...................................... .................... . 2
27 186764 PANEL - Inside Delivery, os ................................. ..... ..... .... .......... ...... ............................. ................ 1
28 102157 SCREW · 10-32 .............................................................. ................................................................. 2

...II. ...II.
-·
...II. ...II.
~/
(I') CD
_. 0
_.
I
(D.. _./~ __ _/~
0 \ • o•
' •'' ~
• r \
•• r; .(
0
~ ..
._ ___ - __\
.. / 0 !
/,'Y. ...
a•
../:"
... . \
·~
<
m
, , ...II. ...II. :::0
\, -__
-• ,'\ 1I
I • \
"""'
en
, ·1 \
' \ --~.
l>
z
c
C)
c:
15;
...II.
CD
...II.
co ./
c
en
,,,, ,,,,
~\ ~\
,,,, ,,,,
,, ,,
,,,, ,,,,
,,,, ,,,, Co)
,,,, ,,,,
,,,, ,,,,
,,,, ,,,,
0 ,,,, ,,,,
<D
::s ,,,, ,,,,
......
c ,,,, ,,,,
-<c.v ,,,, ,,,,
,,,, ,,,,
01
0 ,,,, ,,,,
0
,,,, ,,,,
"1J
jl) ,,,, ,,,,
~
(f) ,,,, ,,,,
0 ,,,, ,,,,
~
Sl>
,,,, ,,,,
.., t,) ../
0
(Q ...II.
...II. N
...II. ~ en
COVERS AND GUARDS
NON-OPERATOR SIDE COVERS- PART 1
Index Part
1 186491 COVER - Tower 2 ............................ ........... ..... .................... ........... .......................... ....................... 1
2 186495 COVER - Mid ...... .............................. ................... .............. ........... ................... ............................... 1
3 186493 COVER - Tower 1 ............................ ...... .......... ...... .............................................................. ............ 1
4 173044 COVER- Feeder Mid ........ ..... ........... .... ............... ..... ................... ............................... .................... 1
5 173054 COVER - Feeder .................................................... ................. ..... ........................... ....................... 1
6 174192 DECAL · Master Power ...... ............. ................ ............... ..... .... ........................................................ 1
7 102165 SCREW- Phillips, 10-12 x 1-1/4"........................ ............... ........................................................... 16
8 001575 SCREW - Phillips, 10-32 x 5/16" ..... ......... ........ ...................... ......................... ........ .. .................... 12
9 014183 SCREW · Head, 5/16-18 x 5/8" ........ .......... .......... ..... ...................................................................... 2
10 173081 BRACKET - Lower Mount ..................... .......................... ..... ..... .... ................................................... 6
11 173082 NUT - Self Clinching ....................... .... ..... ........ ... ..... ..... ......... .................... ..... ........ .. ..................... 6
12 102157 SCREW · Button, 10··32 x 3/8" ......... ..... ................................... ................................. .. ..................... 4
13 173078 BRACKET - Magnet .............................. ............ .. ..... ...... ..... ..... ....................................................... 1
14 101548 CATCH- Magnetic ............. ............... .......... ...... ... ..... ..... ............................................. .................... 1
15 150083 NUT • Lock, 10·32 ................................ ............ .. ............... .......... ........... ..... .... ........ .. ..................... 2
16 001649 SCREW- Phillips, 10-32 x 1/2" ...................................................... ................................................. 3
17 186496 COVER - Filler Delivery ................... ............... .. ... .... ...................................................................... . 1
18 174185 DECAL - Ink Roller Clean up .......... ................. ....... ...... .......................................... .. ................... .. 2
19 174198 DECAL · Night Latch ............. .................... ....... .. ...... ..... .... ..... ........................................................ 2
20 1011 44 NUT • Self Clinching ....................... ......... ........ ............. .... ..... ....................................................... 10
21 173062 RAIL - Upper Cover .................................... .................................. .................... ....... .. ..................... 1
22 014209 SCREW - Hex, 5/16·24 x 5/8" .. ............. ...... ........................ ..................................... .. ..................... 2

COVERS AND GUARDS
1-1 2 Century 3500 Parts Catalog

COVERS AND GUARDS
NON-OPERATOR SIDE COVERS· PART 2
Index Part
1 150083 NUT· Lock, 10·32 ....................................................................................... ................................... 8

2 173066 DOOR· Delivery Oil ......................... ........................................ ................................ ....................... 1
3 173506 DOOR - Stop ......................... ............... .......................................................................................... 1
4 197195 WASHER · .257 i.d x .500 o.d.......... ..... ......... ... ........ ..... ..... .... ..... ...... ............................................. 1
5 102157 SCREW- Button, 10-32 x 3/8" .............. .......... ............... ..... ............................................................ 7
6 001677 SCREW - 1/4-28 x 5/8" (for lower rail) ...................... ..... ...... ........................................................... 5
7 021013 SCREW - Hex, 1/4-28 x 5/8" ............ .............. ... .. ........... ..... .... ......................... .............................. . 1
8 111056 SCREW- Hex, 10-32 x 5/8" ............. ................ ......... ..... .................... ...................... ....................... 1
9 173080 SKIRT- Delivery ......................................... ............... .................... .................... .............................. 1
10 174185 DECAL- Fork Entry ...................... .... ............... ...... .... ..... ................ .... .......... ................ ................... 2
11 173150 CUSHION (Insulator, Foam Delivery) ........ ............... ......................... ...................... ....................... 1
12 173072 COVER - Lower Delivery (nos) ............................ ..... .... ..... .......... .................... ....... ... .................... 1
13 186876 LABEL- Lower Delivery (Century) ..... .......... ..... ..... ..... ........... ........................ ................................... 1
14 186884 LABEL- Lower Delivery (Ruby) .................................. ..... ............... ..... .......... ................................... 1
15 186892 COVER - Lower Feeder (nos) .......... .............. ........... ..... ..... ............................................................ 1
16 186893 LABEL- Lower Feeder ...... ................ .......... .... ...... ..... ...... ................................................................ 1
17 173074 RAIL- Lower ..................... ............... ..... ................. .... ..... ...... .... ..... ...... ......... ................ .... ............... 1
18 193338 WASHER - .257 i.d. ......................... ..... ...... .... ........... ..... ................................................................. 1
19 173083 GASKET - Foam Rail ....................... ......................... ................................... ................................... 2
20 014353 SCREW- Hex, 1/4-28 x 1/2" ............ .............. ................. ..... .... ........................................................ 1
21 173075 PANEL · Inside Delivery .................. ........... .... ........... ......... ..... ..................... ............ .. ..................... 1
22 150084 NUT - Lock, 1/4-20 ................ ................ .... ................. .... ..... ............... ............................................. 2
23 102303 SCREW - Hex, 1/4-20 x 3/4" ............ ......... ..... ................. ..... .... ......................... ............................... 2
24 173077 BRACKET - Oil Panel ........................... ................ .... .......... .......... ..... ...................... .. ..................... 1

COVERS AND GUARDS
2 --------,
3-----..
4-----,
5-------, 23
6 -------.
~---- 2
~---- 4
~- 5
32 - - - --
6
'------- 8
31 - - - - L - - - - - -3
~---- 26
~----- 27
' - - - - - - - - - 28
COVERS AND GUARDS
CHAIN DELIVERY I FEED END SAFETY GUARDS
Index Part
1 186909 GUARD· Tower2 ...... ............................................ ........................................ ..... .... .......................... 1

2 186919 SHAFT- Cam Assembly, C. D. Pivot ................ ................................................................................ 2
3 001833 NUT - Hex, 1/4-20 ..... ............. .......... ..... ........................................................................................... 4
4 100716 NUT- Locking, 6-32 ......................................... ......................... ..... .................................... .............. 4
5 100625 SCREW- Hex Socket, 1/4-20 x 1/2" .............. ............ ..... .... ............................. ........ .. ..................... 4
6 253822 SWITCH ......................................................... .......................... ....................................................... 2
7 100744 SCREW - Phillips, 6-32 x 3/4" .............................. ............... ............................................................ 4
8 186922 BRACKET- Switch, C.D................................... ........ .............. ................................... ..................... 2
9 001778 RETAINING RING- .214 i.d. x .027 .. ................ .................... ...... .... .................... .............................. 1
10 186939 STRUT ASSEMBLY .. .......... ................................................ ......................... ................................... 1
11 191797 WASHER- Plain, .265 i.d. x 5/8" o.d ....... ............... ..... ................................... .... ........................... 1
12 172811 SCREW - Shoulder ................................................................................. ......................................... 1
13 074399 SPACER ................... ........ .................................... ........... .... .... ..... ................ ................................... 1
14 150083 LOCKNUT FLANGE - 10-32 ................................................................ ................... .......................... 1
15 173032 LABEL SCALE .... .... .. ....................... ...... .... ................................... ...... .... ..... .......... ... .. ........... .......... 1
16 180139 CHANNEL- DeliveryWindow ............... .......... .... ................ ............................................................. 2
17 102157 SCREW- Button Head, 10-32 x 3/8" .............................................................................................. 6
18 180514 LABEL - Warning .... ....................................................... ............................. ................................... 1
19 186908 GUARD ASSEMBLY - C.D . ...................................................... .............. ..... ................................... 1
20 186936 FAN ASSEMBLY · C.D. Guard ........ ...... ..... ..... ..... .......... ..... .......................... ................................. . 1
21 174205 GUARD- Feed End ... ..................................... ............ ...... ................................................................ 1
22 101626 SCREW .................. .. ............................ ........................................................................................... 1
23 005071 WASHER ......... ................ ............................................................ ..... ....................... ....... .... ........... . 1
24 102380 SCREW- 10-32 X 3/8", Black Oxide .............. ............... .................................................................. 8
25 254211 STAND-OFF - PCB, 1 /2' .................................................................................................................. 1
26 186795 SHIELD - Intake, Fan ....... ...................................................................... ......................................... 1
27 065833 SCREW.................... ....................................... ............................ ..... ................ .............. .............. .. 1
28 021861 WASH ER ........................................ ................................................................................................ 1
29 196454 SPACER ................... ................................................................................................ .. ..................... 1
30 186421 DEFLECTOR- Fan .... ................................................. ...... ..... ........ ..... ............... ........ ....... ................ 1
31 186422 BRACKET- Deflector, Fan ................................ .. ........... .......... ....................................................... 1
32 187033 PLATE- Tie ............... ...................................... ................................................................. ............... 1
33 102531 NUT -Speed ........ .................................................. ................ ......................... ................................. . 1
34 102348 SCREW ................................................................ ..... ..... ...... ..... .... ..... ...................... .. ..................... 1
35 187188 PCB ASSEMBLY- Fan Speed Cont. .......... .... ......................................... ......... ........ .. ..................... 1
36 180472 KNOB .................. ...... ........ .................................... ..... ..... .... ............................................................. 1
37 187389 COVER - Paper Interrupt Finger ...... .............. ............... .............................. .................................... 1
38 187384 GUARD · Chain Delivery, Fixed ...... ........... .......... ........................ ..... ...... ..... ......... .......... ................ 1
39 102356 SCREW - Black Oxide, 10/32 x 1/2" .. .... ..... ... ... .............. ........... .... ................ .............................. 4
40 072258 LABEL - Warning ................................. ..... .... ... .. ........... .... ..... ........................ ........ .. ..... ................ 1
41 186424 WINDOW - Delivery ............................................. .............. ............... ............................. ................ 1

CRANKS, HANDLES AND KNOBS


Index Part
1 173210 HANDLE - Ratchet ........... ....... 2

oo . . oo . . . . oo . . oo . . . . . . . . . .oo . . . . . oo oo . . . . . oo . . 00 00 . . . . . . oo oo 00 00 . . . . . . . . . . . . . . . . . 00 000 . . . . . . oo . . . . oo . . . .
2 186098 KNOB ...................... .......................... ................. .. .............. ........... ............... ...... ......... .................... 2
3 017715 HANDLE ............................. .............. ............... ...... .............................. ............................................ 1
4 017595 CRANK - Arm ........... 00 . . . . . . . . . . . . oo . . . . . . . . . . 00 . .. ... .. . . . .. 2
. . . . . . . . . . . . . 00 . . . 00 . . . . . . . . . . . . . . . . 00 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . .
5 039642 RING - Plastic .. 0 0 0 0 . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

. .. . . . . . . . . . . . . . . . . . .......... . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . .
6 197194 SCREW -Crank ....... 2

oo . . . oo . . oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . oo . . . oo . . . . . . . . . . . . . oo . . . . . . . . . . . oo . . . .
7 186751 KNOB - Gear Adjustment .. oooooo . . . . . . oooo . . . . oo . . ooooooo ooo . . . . . . . . . . . . 1 00 . . 00 . . 00 . . . . . . oooo . . . . oo . . oooo . . . . . . . . . . oo . . oooo . . oo . . oo . . . . oo
8 016574 WASHER - .315 i.d. x .687 o.d ..... .... .... oo . . . . oo . . . . . 1

. . oo . . oo . . . . . . . . . . . . . . ooooooo . . oo . . . . . . oo . . . . . . 00 . . . . . . . . . . . . . . . . . 0 0 0 0 . .. . . . .
9 016933 KNOB ................................................ ................................. ............................................ ................. 1

10 172630 CRANK - Assembly Chain Delivery ............ ........ 1
oo . . oo . . . . . . . . . . oo . . . . . . . . . . . . oo . . . . . . . . . . . . . . oo . . oo . . . . . . . . . . . . . . 00. . . . . . . .
11 196906 SCREW · Dowel ............... ................ .............. ............... ...... ............. ....... 1 0000 . . . . . .. oo . . . . . . . . . . . . . . .. . . . . . . . . . .
12 179573 EXTENSION • Crank Shaft .............. ........... .... ... ............. ..................... 1 00.00 00 00 oo . . . 00 00 00 . . . 00 00 00 000000 00 . . 00 00
13 017713 CRANK ARM .. 1

oo oo oo . . . . . . . . . ooooooo . . oooo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
14 003042 HANDLE - Lock .. ...... oo . . . . . . . . . . . . . . . . . . . . . . . . . . . 00000 . . . . . . . .... oo 0000 00 1oo . . . 0000 oooo • • 0000 0 00000 0000 0 oo . . . . oo . . . . . . oooo . . . oo . . oo . . oooo 00
15 186099 INDICATOR· Dial ................................. ..... .... ........ 4

oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . oo . . . . . oo . . . . . oo . . . . . . . . . . . . . 00 . . . . . . . . . . . .
16 186268 PLUG .. oo oo . . oo ooo oo ooooooo • • 4

oo . . . . . . . . . . . . oo . . . oooooooooooo . . oooo . . . oo . . oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . oo . . . . . . . . .

TOWERS

TOWERS
17----
'-----12
' - - - - - - - -18
15_/
14----'

TOWERS
ROLLER CONFIGURATION
Index Part
1 187310 INK FOUNTAIN ROLLER & BLADE ASSEMBLY- Metal .. ........... .............. ..................... .............. 1
2 179961 INK DUCTOR - Rubber ...... .... .................... ....... ... .................... ..................... ..................... ............ 1
3 172447 INK METERING- Rubber ................... ............................. ................................................................ 1
4 186131 DIST RIBUTOR RIDER - Nylon ........ .......... ............... ..... ........... .... ................ .................................. 2
5 186703 FIRST INK OSCILLATING - Nylon .. ......... ................ .... ..................... ........................ ..................... 1
6 186140 INK TRANSFER (UPPER) - Rubber ............... ................ ......... ....................................................... 1
7 186141 INK TRANSFER (LOWER) - Nylon ........ .............. ...................... ..................................................... 1
8 186192 OSCILLATING RIDER - Nylon ................... .......................... ..... .................................. .... ................ 1
9 186086 WAT ER OSCILLATING - Chrome .... .......... ............... ....................................................... ............... 1
10 186173 WATER METERING- Rubber ............................... ............................................ .............................. 1
11 186748 PAN - CHROME ............ ..... .............. .............. ........... ...... ..... .............. .......... ..... .............................. 1
12 186166 WATER FORM- Rubber, With Bearings & Gear ...... ......... ..................................... .... ................... 1
12 186232 WATER FORM- Rubber, .\l:ii.1b..Q.u! Bearings & Gear ............ .......................................................... 1
13 186640 SECOND INK FORM - Rubber ......... .............. ....... ..... ..... .... ............... ........... .............. .................... 1
14 186641 THIRD INK FORM· Rubber .... ..... .... ..... ...... .... ...... ............... ..... .................... ............... ..... .............. 1
15 186703 THIRD INK OSCILLATING - Nylon ...................................... ........................................................... 1
16 186216 INK TRANSFER - Rubber .. .......... ...... ......... .... .......... ........... ........................................ ................... 1
17 186703 SECOND INK OSCILLATING - Nylon ... ..... ........... .... ...... ..... ............... ............................................ 1
18 186639 FIRST INK FORM- Rubber ............................................................................................................. 1

TOWERS
r-----9
I
;' L2
I
......____ _ _ _ _ 4
t::=====:::::::::::;========~
c3

TOWERS
DAMPENER TROUGH AND BRACKETS
Index Part
1 186093 BRACKET ASSEMBLY -Trough (O.S.) ................................................ ......... ................................. 2

2 186094 BRACKET ASSEMBLY- Trough (N.O.S.) ...................................................................................... 2
3 186214 FOUNTAINASSEMBLY-Dampener ............................................................................................... 1
4 186252 BRACKET - Dampener Bottle .............. ....................................................... ..... .... ........... ..... ............ 1
5 102419 SCREW - Socket Head, 1/4-20 .......................... ............................................................................. 2
6 178806 PULLEY- Timing, 24Teeth .............. .............. ..... ......... ......................... ........................................... 1
7 186202 BRACKET- Dampener, Motor Mount .............................................................................................. 1
8 102486 SCREW - Hex Flange 3/8-16 x 3/4" .... .............. ................ ......... .................................................. ... 2
9 003586 WASHER ........ ......... ...................... ............... .... ........... ..... .............................................................. 2
10 195259 SPACER- Cam .................................................................................................................. ............ 2

TOWERS
N.O.S.---...,.
Frame
Ref. Metering-\
Socket Assy.
(N.O.S.)
Socket Assy.
(O.S.)
9

TOWERS
DAMPENER PAN ROLLER ASSEMBLY
Index Part
1 186748 ROLLER • Dampener ....... ................ .......... .... ................................................................................. 1

2 197046 WASHER ·Thrust ......... ................... .......... ....... .. ...... ................... ..... .......... ............... ........ ............ 2
3 102420 WASHER - Thrust ............................ ............. .................................................................................. 1
4 014761 WASHER ............ .............................. ..... ........... ........................................... ............... .................... 1
5 102586 SCREW - 1/4-20 X 3/4" ··············································· ····· ········· .................... ................................... 4
6 186708 BUSHING ASSEMBLY- nos .......................... ................ ................................................................. 1
7 186947 BLOCK - Pivot, Metering Lock ......................... ... ..... ...................................................................... 1
8 102505 SCREW - Set, 1/4-20 x 1" ................ .... .... ...... .. ........ ..... ............................................ ..................... 1
9 186722 WASHER - Thrust ......... ......... .......... ..... ..... .......... ...... ..... ................................................................ 4
10 102428 WASHER -Spring .......................................................................................................................... . 2
11 001070 RING - Retaining .............................. .... ............ ........ ..... .............................. ................................... 2
12 186707 BUSHING ASSEMBLy- OS ........ ......... ........ ............... ..... ..................... ................... ..... ..... ............. . 1

TOWERS

TOWERS
DAMPENER METERING AND OSCILLATOR RIDER ROLLER
Index Part
1 186173 ROLLER- Dampener Metering Roller ............................................................................................... 1

2 186192 ROLLER ASSY. - Small Oscillating Roller (Rider) ......................................................................... 1

TOWERS
1 2

TOWERS
DAMPENER FORM ROLLER
Index Part
1 186166 ROLLER· Dampener Form Roller .................................................................................................. 1

2 186146 SHAFT ASSEMBLY ........................................................................... ............................................ 1

TOWERS
8
9
16
7
6 ~
~\ 15
5
"-( (t - - 10
11
4 --.....,,
3
12
1 --------------~

TOWERS
DAMPENER FORM SOCKET ASSEMBLY (OS)- PART 1
Index Part
1 101964 SET SCREW - Cup Point Blk. 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 1

2 186199 PIN- Clean Up ooooooo• •oo ooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooo• •oo oooooooooooooo. . . oo. . 1
3 001726 WASHER · · · oo· · · oo ••oo•oo• • o o · · · · · · o o • oo o o o • o o · · · · o o o o • • • o o o o o o o o o . . o o · · · · · · · · · · · · o o · · · · · · o o · · · · · o o o o • o o · · · · · · · · · oo · · · · · o o · o o · · · o o · • o o • oo o o · · · · · · 1
4 102578 PLUNGER ·Spring, 1/4-20 OOOO o o o o o o o o o o . o o o o o o o o o . . o o · · · oo•oooooooo.oooo.oooo . . oooooooooooo . . ooooooooooooooo • • oo.ooooooooooooooooooo. 1
5 172403 SCREW - Drive oo . . . . . . . o o . o o o o o o o o o o o o o o o o o o o o o o o o o o o o oo o o o o o o o o o o o o o o o o o o o o o o o oo oo o o o o o o o o o o o o o o oo o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o · · 1
6 172947 INSERT · BRASS 0000 0 0 0 0 0 o o o o · 0 0 0 0 0 0 0 0 0 0 0 0 0 0 000 000 0 0 0 0 0 oo . . . . .oo . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 • • 0 0 0 0 0 0 0 0 0 0 0 0 0 o o o o • 000 1
7 102243 SET SCREW- 1/4-20 x 3/16" 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 00 0 0 00 0 0 0 0 0 0 0 0 1
8 014304 SCREW -1/4-28 X 1-1/2" OOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOO OOOO OOOOOO OO OOO OOOOOOOO OOOO OOOOOOOOOOOOOOO OOO OOOOOOOOOOOOooOOOOOOOOOOOOOOOOOOOOO 1
9 197294 SPRING - Compression o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o . . . oo . . o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o oo o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o · · 1
10 102228 SET SCREW- 1/4-28 o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o ooo oo o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o ooOOOOOO OOOOOOOO OOOO OO OO OOOO ooOO OO 1
11 102586 SCREW • 1/4-20 X 3/4" 0 0 0 0 0 0 000 0 0 0 0 0 0 0 0 0 000 00 00 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 00 000 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 00 0 0 0 0 0 0 0 0 0 0 0 00 00 0 0 0 0 0 0 00 . . . 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 1
12 186733 COVER ASSEMBLY ·Adj. (Small) o o o o oo o o o o o o o o oo o oo . oo o o o o o o o oo oo o o o o o o o o o o o o oo o o o o o o o o oo o o o o o o o o o o o o o o o o oo 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1
13 190631 SPACER - T97S o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o oooo o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o oo o oo o o o o o o o o o o o o o o o o o o o o o o o o o o · 1
14 186189 SOCKET ASSEMBLY- 0-Form o o o o o o o o o o o o o o o o o o o o o o o . oo o o o o o o oo o o o o o o o o o o o o 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 o o • • • o o o o o o o o o o o oo o o . . . o o . 1
15 186149 BLOCK - Pivot 0 0 0 0 . 0 0 00 . 0 0 . 0 0 00 00 00 000 0 0 0 0 . 0 0 00 o o o o . 00 0 0 . 0 0 00 . 0 0 000 00 0 0 . 0 0 0 0 00 00 . 00 0 0 0 0 00 0 0 . 0 0 00 00 0 0 . 0 0 0 0 . . . 00 00 00 0 0 0 0 . . . 00 00 . 00 00 0 0 0 0 0 0 0 0 . 0 0 . 1
16 102541 T-SCREW ·Slotted Nylon 10-32 oooooooooooooooooooooooooooooooo oooooooooo oooooooooooooooooooooooooo oooooo oooooooooooooooooooooooooo 2
17 102357 SCREW • 10-32 x 1/4", Black Oxide o o o o o o o o . o o o o ooooooooooooooooooooooooooOOOOOOOOOOOOOOOOOOOOOOOOOOooOOOOOOOO OOoo OOOOOOOOOOOOOO 2

TOWERS
~----------------- 6
~--------- 7
..,.----- 9
~~ -0)
5 -----....._ 14
4------.
12 - - - - - - . . . _ '------- 11
3----------.
2- - - - - - -
~13

TOWERS
DAMPENER FORM SOCKET ASSEMBLY (NOS)- PART 1
Index Part
1 186199 PIN - Clean-Up ... .............................. ..... .................... ...... .............. .................................................. 1
2 190631 SPACER - T97S ................ ......................... ......................... ..... .... ......... ...... ..... .................. ............ 1
3 186733 COVER ASSEMBLY - Adj. (Small) .... .............. ................................................................................ 1
4 102228 SET SCREW - 1/2-28 ......... ................... ..... ..... .......................... ..... .............. ............... .................... 1
5 102587 SCREW - Black, 1/4-20 x 1-1/4" ... .............. ....................................... ...................... ....................... 1
6 014304 SCREW - 1/4-28 X 1-1/2" ..................... ......... ....... ................ ........................................................... 1
7 102243 SET SCREW- 1/4-20 X 3/16" .......................... ...... .......................................................................... 1
8 197294 SPRING - Compression ....................................................... ............................................ ............... 1
9 172947 INSERT - Brass .. .................... ............... ............... ..................... ........................................ .............. 1
10 172403 SCREW- Drive ......... ........................................... ............................................. ............................. . 1
11 102578 SPRING - Plunger, 1/4-20 .. .............. .... ....... ....................................................... ...... ....... ............... . 1
12 001726 WASHER ............. ............................................. .................. ............................................................ 1
13 186190 SOCKET ASSEMBLY ............ ................................................................................. ......................... 1
14 186149 BLOCK - Pivot ..... ............................ ..... ............... ............................. ................ ......... ..................... 1
15 102541 T-SCREW- Slotted Nylon 10·32 .............................. ................... ................ ................................... 2
16 102357 SCREW - 10-32 x 1/4", Black Oxide ................................. .......... .................... ................ .............. 2

TOWERS
O.S. Frame
1' 2, 3, 4 - - - - " " " '
Ref. D-F Socket Assy. (0.5.)

TOWERS
DAMPENER FORM SOCKET ASSEMBLY (OS)- PART 2
Index Part
1 186721 WASHER- Thrust, 2.25" ................................................................................................................. 1

2 102428 WASHER - Spring, Black, 1.17" i.d . ...... ..... ..... .......... ........... ..... ........... .... .... .................... ............... 1
3 186722 WASHER - Thrust, 1.50" ................................................................................................................. 1
4 001070 RING - Retaining ............................................................................................................................ 1
5 186170 STOP - Eccentric ................................. ................ .............................. ..... .... ..... ...... .... ..................... 1
6 150087 NUT .................... ...... .......... ..... ......... ..... ..... ............................... .... ................ ..... .... ......................... 1

TOWERS
N.O.S. Frame
------5
1, 2, 3, 4
Ref. D-F Socket Assy. (N.O.S.)

TOWERS
DAMPENER FORM SOCKET ASSEMBLY (NOS)- PART 2
Index Part
1 186721 WASHER- Thrust, 2.25" ................................................................................................................. 1

2 102428 WASHER - Spring, Black, 1.17" i.d . ...... ..... ..... .......... ........... ..... ........... .... .... ................................... 1
3 186722 WASHER - Thrust, 1.50" ............................................................................... .................................. 1
4 001070 RING - Retaining ... ........... ..................................................................... ......................................... 1
5 186171 STOP - Eccentric ............................................ ............................................ .................................... 1
6 150087 NUT ......................................... .............. .................................... .................... .................................. 1

TOWERS
~--- 4
2-/
~-./
/
/
'-'---~ ----7
----8

TOWERS
DAMPENER METERING ROLLER SOCKET (OS)
Index Part
1 186095 SCREW ASSEMBLY - Adjusting (Metering Roller) ...... ..... ........... .......................... ....................... 1
2 022654 CLAMP - Bearing ........................................ ....... ... .................... ......... ......................... .................... 1
3 102588 SCREW - Black, 10·32 x 5/8" .......... ............................................................................................... 1
4 186678 SOCKET - Large Metering ................... .......... ........... .................... ................ ......... ......................... 1
5 186169 SOCKET - Small Metering ................ .......... ............... ........... ........................ .................... ............... 1
6 102292 SETSCREW- 3/4" ............ ................ ............. ...... ............ .............. ................................... ............... 1
7 186093 BRACKET- Trough, O.S................................................................................... .............................. 1
8 102418 SCREW - Socket, Black 1/4·20 x 1/2" ........ ............................................................. .. .................... . 2
9 102426 WASHER - Spring Bent 5/16" .......... .......... ......................... ............................................................ 1
10 102425 SCREW - Hex Socket, 1/4-20 x 3/8" .............. .......... ....................................................... .............. . 1
11 014464 RING - Grip .................... ................... ......................... ..................... .............. .......... .... .................... . 1

TOWERS

TOWERS
DAMPENER METERING ROLLER SOCKET (NOS)
Index Part
1 186095 SCREW ASSEMBLY, Adjusting (Metering Roller) ............. .......... ........................... ....................... 1
2 014464 RING · Grip ........................ ........... .... .............................. .......... .......... ..................... ........... ............ 1
3 022654 CLAMP - Bearing ................ .............. ......................................................................................... ...... 1
4 102588 SCREW - Black, 10-32 x 5/8" .......... ........... ............................................................. ....................... 1
5 186678 SOCKET - Metering, Large .......... .............. ......................................... ..................... .... .... ............... 1
6 186625 SOCKET - Metering, Small (NOS) ... .............. ...... ........................................................................... 1
7 102292 SETSCREW - Black, 3/4" ...................................... ............................................................ .............. 1
8 186094 BRACKET- Trough (NOS) ............................. .. ........ ......... ................ .............. .... ...... ..................... 1
9 102418 SCREW - Black, 1/4-20 x 1/2" ............................. ...... ...................................................................... 2
10 102426 WASHER- Spring Bent, 5/ 16" ....................... ................................................................................. 1
11 102425 SCREW - Hex Socket, 1/4-20 x 3/8" .............. .. ........ ........................ .......... ..................... ............... 1

TOWERS

TOWERS
DAMPENER MOTOR ASSEMBLY
Index Part
1 197561 BELT - Timing ...... .............................. ..... .... ..... ................................................................................ 1

2 186203 PULLEY- Timing, 30 Teeth ............. .......... ....... .. .............................. ......................... .................... 1
3 150084 NUT - 1/4-20 ..................................... ............................................................................................... 3
4 187217 MOTOR ASSEMBLY - Dampener ............... .................................................. .............. .................... 1
5 001706 WASHER - Lock ......................................... ............... ........................................ .............................. 1
6 001690 SCREW- 10-32 X 5/16" ····· ··································· ·········· ································································· 1
7 102303 SCREW - 1/4-20 x 3/4" Hex Flange ...... ............... ..... ...................................................................... 3
8 021203 WASHER ....................... ................... .......................... ..... .... ............................................. ............... 2
9 102419 SCREW - Socket Head, 1/4-20 ............ ...... .... ........... ...................................................................... 2

TOWERS

TOWERS
DAMPENER AIR CYLINDER & SHAFT ASSEMBLY
Index Part
1 179370 CLEVIS Piston Rod .......... ... ................ ..... .... ............................... ................ .................................. 1
0
2 001834 NUT · Hex, 5/16°24 ........... ............... ..... ..... ....... .. ........... ..... ......... ..... ...... .... ..... .................. ............ 1
3 186195 CYLINDER ·Air .. .............................. ............... ................................................... ............................. 1
4 197440 ELBOW Male Swivel ...... ..... ......... ................ .. ............................ .................... .......... .... .......... ...... 1
0
5 001049 RING · Retaining ..... o ... .. ............. .. ............ .... . ... ................ . .......... o .. ... ......... .. .. . 1
... .. .. 0 .. .. .... .. .. ... .. ......
6 186194 STANDOFF · Air Cylunder Pivot ...... ................ ................................................................................ 1

7 014510 "E" RING ...................................................................................... 0 1
.. .............................................. . .
8 080099 SPRING ........................................... ................................................................ ............................... .

9 186731 SHAFT ASSEMBLY - Dampener .......... .................................... ...................................................... 1
10 100890 SCREW · Set .................................................. ................................................... ................ .............. 2
11 187322 PIN .................................. .............................. ..................... ................ ......... ............ ....... ................ 2
12 186196 STANDOFF· Anchor Joint .......................... ................................................. ...... ...... ....................... 1

TOWERS
2 - - - -.. . . .
17~
3~
4, 5 - - - - - - - - - ,
6, 7--------.
. - - - - 16, 18
8,9
10, 11 , 12

TOWERS
OSCILLATOR LEVER SYSTEM
Index Part
1 186082 SHAFT ASSEMBLY- Dampener Oscillator Roller .. ....................................................................... 1

2 186086 ROLLER ASSEMBLY · Chrome Oscillator ........ ............................................................................. 1
3 102587 SCREW- Black, 1/4-20 x 1-1/4" ............................................................................ ......................... 3
4 186088 COUPLING - Oscillator Roller ......................................................................................................... 1
5 102465 SCREW - Set, 1/4-20 ............................................................................................... ...................... . 1
6 186047 STUD- Oscillator Lever ................................................ .... ..................... ....................................... . 2
7 102569 SETSCREW - Black, 1/4-20 ........................................................................................................... 2
8 102313 ROLLER - Track Crowned, 10-32 ... ........... ..... ......... ...... ................................... .............................. 3
9 150083 NUT - Lock, 10-32 ................. ................ .......... ..... ..... ..... ................................................................. 3
10 186241 SUPPORT - Oscillator Lever, Machined ........................................................................................ 1
11 102425 SCREW - Hex Socket Head, 1/4 - 20 x 3/8" .. .. ........ ......... ......................... ..................... ............... 4
12 186243 LEVER ASSEMBLY- Oscillator Ink Dampener ........ ..... .... .............................. .............................. 1
13 102313 ROLLER - Track, Crowned, 10-32 ....... ................ ......................... .................................................. 2
14 007076 PIN • Taper ....................................... ............... ..... ..... ...................................................................... 1
15 150083 NUT· Lock, 10·32 ............................ ..... ..... ........... .... .......... ...... ......... .......... ................................... 2
16 102502 ROLLER- Track Cam, 1/4-28 .............. .............................................. ............................................. 1
17 186092 GEAR ................. ..... .......................... .... .......... ............ ..... .... ............... .......... ............... ..... .............. . 1
18 150085 NUT · Lock, 1/4-28 ......................................... ...... ....................................................... ................... . 1
19 186048 SUPPORT · Oscillator Lever .......................... ................................................................................. 1
20 186045 LEVER ASSEMBLY- Ink Oscillator ....................................................... ......... ............................... 1

TOWERS
~--- 6
Ref. Clean-Up
Trough Assy. _ _..../

TOWERS
OSCILLATOR ROLLER ASSEMBLIES
Index Part
1 186723 COUPLING - Oscillating Roller ......... .... ..... ....... ... .............................. ......... ............ ....................... 1
2 102465 SET SCREW - 1/4-20 ................... ......... ..... ....... ... ............... .................................... ....................... 3
3 186088 COUPLING - Oscillating Roller ......... .... ......... ..................................... ..... .... ............ ......... .............. 2
4 187112 LEVER ASSEMBLY - Ink Clean-Up .... ................ ........................................................................... 1
5 187159 SCREW - Special ............................. .......................... .... .............................. ................................... 2
6 186703 ROLLER ASSEMBLY - Ink Oscillating ........... ................. .................................. ....... .. ...... .............. . 3
7 102586 SCREW- Black, 1/4-20 x 3/4" ........................................................................... .............................. 9
8 186705 SHAFT ASSEMBLY - Oscillating Roller #1 .... ........... ...... .... .............................. ....... .... .... ............... 1
9 186083 SHAFT ASSEMBLY - Oscillating Roller #2 and #3 ............ ............................................................ 2
10 007076 PIN - Taper ...................................................... ..... .................................................. ......... ................ 3
11 150084 LOCKNUT ........... ......................... .... .......... ................ ..... ..... ........... ................... ............................. 2

TOWERS
10 - - -
~7

TOWERS
INK FOUNTAIN ASSEMBLY- PART 1
Index Part
1 187310 ROLLER & BLADE ASSEMBLY - Ink Fountain ........................................... .................................. 1

2 186097 PLATE - Ink Pan End (OS) .................................. ......................... ..... ............... .......... .................... 1
3 186034 PAN - Ink ......................................... ................................................................................................ 1
4 173365 SPRING - Screw Tension ........................... ..... ............................................ ............... .................... 1
5 179974 SCREW - Ink Contro~ ...................................... ............ ..... .... ............... .......... .................... .............. 17
6 187093 GUARD ............... ............... ............................. .. ... ......................... .................................................. 1
7 102332 SCREW- Black Oxide, 10-32 x 3/8" ................................... ............................................................ 2
8 102418 SCREW - Socket - 1/4-20 x 1/2" ..... ......... ...... ......... ..... ................ ..... .............. ............................... 4
9 172969 LABEL - Scale ........................ ......... ..... ...... ........... ..... ..... .... ............................................................ 1
10 186096 PLATE- Ink Pan End (NOS) ................................. .......................................................................... 1
11 186033 PIN - Ink Fountain Pivot .... ................... .......... ................. .... .......... .............. ................ .................... 2
12 100546 SETSCREW • Pivot, 1/4-20 x 5/16" ................. ............................... ............................. .................... 4
13 014158 SCREW .............. ................................... ............... ........................................................................... 5
14 000666 WASHER ............. ............. ................ .............. .. ... ..... ...... .... .......... .................................................. 5

TOWERS
:~ bo\""rT---~~
4 f1i~
7
£',
~2
t-
5~

TOWERS
INK FOUNTAIN ASSEMBLY- PART 2
Index Part
1 186031 ROLLER • Thrust Ink Pan ............. .... ..... ..... ..... ......................................................... ....................... 2
2 186032 ROLLER • Thrust Ink Pan .. ........... .... ..... ..... ....................................... ......................... .................... 2
3 001047 RING - Snap ................................................................................................................................... 2
4 186030 PIN - Ink Pan .................... ..... .......... ..... .......... .. .......................................... ............... ..................... 2
5 001772 WASHER - Friction .......................... ........................ ........... ............... ............................................. 2
6 186062 EYE BOLT ASSEMBLY ..... ................................... ........... ................................................................ 2

TOWERS
Ref. Ink Sw eep Assy.

TOWERS
INK FOUNTAIN ROLLER DRIVE SYST EM

Index Part
1 014788 WASHER ............ .................................................. ............................................. .............................. 2

2 102303 SCREW- Hex Flange, 1/4-20 x 3/4" .................... .................... ....................................................... 2
3 186015 GEAR - Ink Roller Adj. Assy............. .......... .......................... .............. ............................................. 1
4 186274 LEVER STOP - Ink Sweep Assy. .......... ..... ......................... ..................... ....................................... 1
5 102430 WASHER- Thrust (!.00) .................................................................................................................. 1
6 186266 LEVER STOP- Ink Sweep Assy. ...... ......... ......................... ............................................................ 1
7 001786 RING - Retaining .................................. ............................................. .... ..................... .................... 1
8 197474 SPRING -Extension ......... ................... ................................ ........................ ................ .................... 1
9 186039 CRANK ASSY. ..................................................................... ........................................................... 1
10 001080 RING - Retaining .............. ................ .... ......................................... ............... ................................... 1
11 197052 BEARING - Thrust ................................. .................................... .... ............... ................................... 2
12 197476 THRUST WASHER - Modify ................................................ ........... ................................................ 2
13 197475 SPRING · EXtension ..... ........................ ............................... .... ........... ......... ................................... 1

TOWERS
1, 4 , 5 - - - '

TOWERS
INK RATCHET HANDLE STOPS

Index Part
1 102538 NUT - Hex 1/4-20 ................................... .... ........... ..... ........................................ ............................. 2
2 187272 ST OP PIN TUBE - Ink Ratchet .............. .......... ...... .................... .... .......... ........................................ 1
3 101483 SCREW - Cap .................................. ..... ..................... ..... .......... ..... .... ............... ....... .... ................... 1
4 187273 STOP PIN TUBE - Ink Ratchet. .............. .... ..................... ......................... ....................................... 1
5 100891 SCREW- Cap ............................................ ..................................................................................... 1

TOWERS
12

TOWERS
INK FOUNTAIN SWEEP ASSEMBLY

Index Part
1 001721 WASHER .............................................................. ...... ..... .... ..... ..... ...... ..... .... ..... .............................. 1
2 102543 NUT- Elastic Zinc 1/2-20 ........................... ........... ...... ......... ............... ..... .... ..... .............................. 2
3 014718 WASHER - Spring ......... ................... ..... ..... .......... ...... ..... ..... .... ..... ...... ..... .... ................................... 1
4 102433 WASHER - Friction 33/64 ................. ..... ..... ............................... .... .......... ...... .................................. 2
5 193647 WASHER .............................................................. .................... ................ .... ................................... 2
6 102418 SCREW- Socket 1/4-20 x 1/2" Black ... ...... ..... .... ..... ........... ..... ................... ................................... 1
7 186017 INK SWEEP SHAFT, CAM & GEAR ASSEMBLY .... ...... ..... ..... ...... ..... .... ..... .... .............................. 1
8 001075 RING - Retaining ............................ ...... ............ ... ..... .... ................ ......... ..... ................ .................... 1
9 190149 WASHER ....................... ...................................................... ..................... .... ................................... 1
10 001526 SET SCREW .................................... ..... ..................... ..... .... ..... ................ .... ................................... 1
11 014576 PIN - Driv. Lok.................................. ..... ..... .... ................. ..... ..... .... ........... ..... .................................. 1
12 150084 NUT .................................................. ..... ..... .......................... ..... .... ........... .... ................................... 1
13 186016 BRACKET - Ink Sweep .. ........................ ..... .... ...................... .... .......................... ......... .................... 1
Century 3500 Parts Catalog 3-4 1

TOWERS
: ,,
~&10, 11 ,1!
8------------------~
''------13
' - - - - - - - - 14
15 ----------------..
...
'------1

TOWERS
INK DUCTOR ASSEMBLY
Index Part
1 150083 NUT - Lock, 10-32 000 00 00 000 00 000 00 0000 00000 00000 0000 0000 0000 0 0 00000 00000 0000 00000 0000 0 1
00 00 00 00 00 0 0000 0 0000 0000 0 0000 0 0 00 00 0 0000 00000000 000 00
2 102310 STUD· 1/4-20 ooooooooo ooooooo ooooooooooooooo ooooooooooooooo ooooooooooooooooooooooooooooooooooo oooo ooooo ooooo ooooooooooooooooooo ooooooooooooo• 1
3 150084 NUT - 1/4-20 00 00 00 00 0000 00 00 000000000 00 000000000000 00 00 00 00000000 0 00 00 00000000000000 0 0000 00 0 1
00 0000 00 0000 0 0000000 00 0000 00 000 00 000000000000000000
4 196997 WASHER - Thrust OOOOOOOOOO OOOOO OOOOooOOOOOOOOO OOOOo OOOOOOOOOoOOOOOO OOOOO OOOO ooOOoOOOOooooooooooo ooooo oo ... oooOooooooo oooooooo.. oo 1
0000 00 000
5 001049 RING · Retaining oooooooooooooooooooooo ooooooooo oooooo oooo

0000 0 oooo ooooooooooooooooooooooooooooooooooo oooooooooo oo 1
0 00 000 00 000 00 000000 0 0000 00 0
6 021203 WASHER 00 0000 00 00 00 0000 0 00000000000000000 0000 00 00 000 00 0000000 0000 0 0000 00000 00 00 00000000000 0 1
0000000 00 00000 00 0000 0 000000000000 00 00 00 0000000000000
7 014741 WASHER - Spring 0 000 00 0000000000000000000000000000 00000000 000000 00 0000000000000 00 00000000000000 000000000000 0 1 0000000000 0 00 000 00 00 000 00 000
8 187087 BAR - Tension Ductoroooooo.......... o.... .... o.. oo ...... .. o.... ooo oooo ooooooooooo ooooooooo ooooooooooooooooooooooooooooooooooo ooooooooo ooo 1
9 054409 SPRING ooooooooooo oooooooo oooooooo oOoooooooooooo oooo ooooooooooo oOOoOoooo ooooooooooo oOooo ooooooooo oooooooooooooooooooooooooooooooooooo oooooooooooo 1
10 001049 RING - Retaining 0000 0 00 0000 0 00 000000000000000000000000 00 00 0 000 0 0000 0 1
0000000000 00 000 00 00000000000000 000000000 00 00000000000 00 000 00 000000 00 0000
11 021203 WASHER 0000 00 00 00 000 00 00 000 00 00 0000 000000 0000 00 00 000 00 00 0000 0 00 000 00 00000000 0 1
00 000 0000 00 00 00 00 00 00 00 00000000 00 0000 0 00000000 00 0 00 000 00 00 0000 00 00
12 014741 WASHER - Spring ooooooooo

000 00 00 0000 00 0000000 00 00000000 00 000 0 00 0000 0000 0 00 00 00 0000 00 0 1
00 000000 00 0000000000 00 000 0000000 0000 00 000 00 00000 00000
13 187090 LEVER - Ductor Roller Carrier oooooooooooo oooooooooooooooooooooooooooooo oooooooooooooooooooooooooooooo oooooooooooooo ooooooooooooooooo 1
14 187088 SHAFT - Ductor Roller 00 00 00 00000000 00 000 00 00 0000 0000000 00 00 0 00 00 00 00 0 0000 0 00 0000 00 00 0 0 1
0000 00 00 000000000 0 000000000000 00 00000 00 00 00 00 0000 00
15 179961 INK DUCTOR ROLLER ASSEMBLY oooooooooo oooooooooooooo .. ...... oooo oooooo oooo ooooooooooooooo ooooooooooooooooo 1
00 00 00 00 0000 000
16 001936 PIN -Taper oooo ooooooooooo

000 00 00 00 0 00 00 00 0 00 000000000000000000 00 000 00 000 00 0000 00 00 00 000 00 000 1
00000000000000000000 00 000 00000000 0 0000 0 00 00 000 00 00 0
17 187089 LEVER - Ductor Roller P ressure ooo oo .... oooooo

00 00 0000 00 00 000 . . . . 00 00 00 . . . . 1
00 00 00 00000000 00000000 00 00 00 00 . . . 0000 00 000000000000 00 000
18 001073 RING · Retaining 0000 0 00 00 00 0 oooooooooooo oooo oooooooooo ooooo ooooooooooooooooooooooooooooooooooo oooooooooooo 3
00 000000000 00 000 00 00000000 0 . . . . 00 0
19 196997 WASHER - Thrust ooooooooo

00 000 00 0000000000000 000000000000000 OOOOOOOOOoo ooOOO oooooo ooooooooooooooooooooooooooooooooooooooo oooooooooooo 1
0 00 00
20 186063 DUGTOR SHAFT ASSEMBLY oooooooooooooooooooooo oooooooooooooooooooooooooooooo oooooooooooooooooooo ooooooooooooooooooooooooooooooo 1

21 197480 CAM FOLLOWER - 5625 EC 1
00 0000 00 00 0000 00 00 00 000000 00 00000000 00 00 00 0000 00 0000 0000 00 00 00 000000 00 000000 000000 . . . . 00 00 000000 0000 000

TOWERS

TOWERS
INK METERING AND UPPER INK TRANSFER ROLLER
Index Part
No. No. Description Quanitity
1 172447 ROLLER ASSEMBLY o · Ink Metering (Rubber) 0000 0 0 00 000 0 000000 000 0 0 00 00 0 00 000 00 0 00 000 0 0000 0 000 000 0 0 00 0 00 0 0 000 000 00 000 00 00 1
2 186140 ROLLER ASSEMBLY · Ink T ransfer (Upper) (Rubbe r) 00 000 00 0 000 0 00 0 00 00 0 0 00 0 0000 0 000 000 0 0 00 000 00 00000 0 0000 00 0000 0 000 0 0 1

TOWERS
' - -1

TOWERS
LOWER INK TRANSFER ROLLER
Index Part
186141 ROLLER- Ink Transfer (Lower) (Nylon) .......................................................................................... 1

TOWERS

TOWERS
JUMBO INK TRANSFER ROLLER
Index Part
1 186749 STUD· Pin ...... .. ............................................................................................................................. 2

2 197449 BOLT- Eye ..................................................................... ............. ................................................... 2
3 186216 ROLLER ASSY - Jumbo Ink Transfer........................................................................................... 1
4 197447 SPRING - Compression ................................................................................................................. 2
5 186219 NUT - Knurled (Jumbo) ..... ............... .......... ..... ................................................................................ 2
6 102465 SET SCREW - 1/4-20 Cone Zinc .................... ...... .......................................................................... 2
7 001049 RING - Retaining ............................................................................................................................ 4

TOWERS

TOWERS
INK DISTRIBUTOR ROLLERS
Index Part
186131 ROLLER - Ink Distributor (Nylon) .................................................................................................... 2

TOWERS

TOWERS
INK FORM ROLLERS
Index Part
1 186639 ROLLER · #1 Ink Form ooo . . 000 000 0 0000 0 000 000 0 00 00 0 0000 00 0 0 000 0 00 0 0 000 0 0000 0 000 0 0 0 00 000 0 0000 00 0 0 0 00 00 000 00 000 000 0 0 0 00 0 0 0 0 000 0 0 000 00 000 00 0 1
2 186640 ROLLER · #2 Ink Form 0 0 0 00 000 000 0 0000 0 000 000 0 0000 0 oooo oo 0 0 000 00 000 000 0 0000 0 000 000 00 000 0 000 0 00 000 00 00 000 00 ooo ooo 0 0 000 0 0 0 0 0000 0 000 oo ooo 00 0 1
3 186641 ROLLER · #3 Ink Form 0 0 0 0 0 0 0 0 OoO 0 0 0 0 0 0 000 000 0 oOOO o 0000 00 0 0 000 00 000 000 0 oOOO o 0 0 0 0 0 0 0 0 0 0 0 o OOO o 00 000 00 0 0 0 0 0 0 0 oOO o o o o O OOo 0 0 0 0 00000 000 0 0 000 00 0 1

TOWERS
I/"" ,
I ""' '
I \
5 I
4 '
I
"" "\]'
'
\ I
1 '
/ "---7
'
""'
""' '
""' '
2
10
6- -

TOWERS
INK FORM SOCKET #1 (OS)
Index Part
1 197444 SPRING - Compression ..... .................... ........ ................. ......... ..... ................ .................................. 1
2 196884 NUT - Hex ...................... ............... ........................ ...... ......... ..... .................... ............... ................... 2
3 186142 BLOCK- Pivot (Inking) ........................ ........... .. ............................ ......... ......................................... 3
4 100185 SCREW - Nylok, 10-32 x 1/2" .......... ...... ..... ..... ......... ................................... .................... ............... 1
5 186726 COVER - Retaining Plate ................. .......... .......... ...... ..... .... ................ ......... ..... .............................. 1
6 197546 SPRING- Compression ....................................... ........... .............. .................................................. 1
7 197209 SPRING- Compression ....................................... ........... ................................................................ 1
8 102540 NUT - Hex Adjustment ...... ............... ..... ................ ..... ...... ..... .............. ............... .............................. 1
9 186398 SOCKET - Ink Form #1 (OS) ........... ...... ..... .... ...... ........... ..... ..... ......... ..... ................. .. ..................... 1
10 186393 BLOCK - Link, Machined (OS) .................................. ...... .......... .... .................................................. 1

TOWERS
I '
I '
"' '
"'
~-------------- 3
~: '
~----------- 7
,----------8
'
'
'
'
1 --------------~ '------ 9

TOWERS
INK FORM SOCKET #1 (NOS)
Index Part
1 186394 BLOCK · Link, Pivot Assembly (NOS) ............. .......... ..... ................................................................. 1
2 102540 NUT- Hex ..... ............ ..... .................... ..... .............................................. .... ....................................... 1
3 197209 SPRING- Compression ................... .............. ............................... ..... ........... .................................. 1
4 186399 SOCKET - Ink Form # 1 (NOS) .............. ..... ..................................................................................... 1
5 100185 SCREW - Nylok, 10-32 x 1/2" ..................... ............... ...................................................................... 1
6 186726 COVER - Retaining Plate ...... ................ ..... .... ...... ...... ..... .... .............................. .............................. 1
7 186142 BLOCK - Pivot (Inking) ........................ ........... ..... ......... .............................. .................................... 2
8 196884 NUT - Hex ...................... ............... ................... ..................... .................................... .. ..................... 2
9 197546 SPRING - Compression ................................................. ................................................................. 1
10 197444 SPRING - Compression ... ..................... ......... ...... ........... ............................. ............ ....................... 1

TOWERS
(
\
4 -----.
\
3 --------. )
7 ------..
9 _ _______,

TOWERS
Index Part
1 187303 BLOCK · Pivot ................................................................................................................................ 1

2 197443 SPRING- Compression .................................................................................................................. 1
3 186744 SOCKET - Ink Form, #2 (OS) .......................................................................................................... 1
4 102540 NUT - Hex ............................................................................................................................ ............ 1
5 186726 COVER- Retaining Plate .................................................... ............................................................ 1
6 100185 SCREW- Nylok ........................................................................ ...................................................... 1
7 186142 BLOCK - Pivot, Inking ..................................................................................................................... 1
8 196884 NUT - Hex ............................................................................. ........................................................... 1

TOWERS
'
)
I
I r------ 4
\ _,---- 3
,---7
~8
"-------- 9

TOWERS
Index Part
1 187303 BLOCK · Pivot ................................................................................................................................ 1

2 197443 SPRING -Compression ..... .............................................................................................. ............... 1
3 186745 SOCKET - Ink Form, #2 (NOS) .... ......... .......... ................................................................................ 1
4 102540 NUT- Hex ..................................... ................... ..................................... ........................................... 1
5 186726 COVER - Retaining Plate ............................... ............ ..... .... ............................................................ 1
6 100185 SCREW - Nylok .................................... ...... ......... ..... ................ ...................................................... 1
7 186142 BLOCK - Pivot, Inking ........ .................... .......... ..... ..... ..... ................................................................ 1
8 196884 NUT- Hex ...................... ............... ........................................ ......................... ........... .. ..................... 1

TOWERS
2 -------
I
I
1----.... I ,--------- 4
\ ~--- 3
0 5
~6 r--- 7
'--- 9

TOWERS
Index Part
1 187303 BLOCK · Pivot ................................................................................................................................ 1

2 197443 SPRING- Compression ..... .................... .................................................................. ........ ............... 1
3 186746 SOCKET - Ink Form, #3 (OS) .......................................................................................................... 1
4 102540 NUT - Hex ............................................................................................................................ ............ 1
5 186726 COVER- Retaining Plate .................................................... ............................................................ 1
6 100185 SCREW - Nylok ........................................................................ ...................................................... 1
7 186945 BLOCK - Pivot, Inking ..................................................... ................................................................ 1
8 196884 NUT - Hex ............................................................................. ........................................................... 1

TOWERS
//\ 2
/ \
(
\
4
\ 1
3
)
/
7 ------
8 ~
g _ ______/

TOWERS
Index Part
1 187303 BLOCK - Pivot .. ................ ..... .......... ..... .......... .. ....................... ..... ......... ......................................... 1
2 197443 SPRING - Compression ......................... ............. ................ .............. ........... ...................... ............ 1
3 186747 SOCKET· Ink Form, #3 (NOS) ......... .... ................ .............................. ............................................ 1
4 102540 NUT - Hex .......................................... ..... ......... ............................................. .................................. 1
5 186726 COVER - Retaining Plate .................................................... ................ ............................................ 1
6 100185 SCREW - Nylok .......................................... ................... ................................................................. 1
7 186945 BLOCK · Pivot, Inking ..................................................................................................................... 1
8 196884 NUT- Hex ...................... ............... ..... .................... ............... ........................................ ................... 1
9 197444 SPRING - Compression ................... .............. .......................... ....................................................... 1

TOWERS
~----- 1
8,10, 11, 12,13 ------~

O.S. Frame
14,15 - - - - - - - - - - - - - .
------ 16, 17,18

Ref. Ink Form Socket Assy.
#1 (OS)~ ~ Ref. Ink Form Socket Assy,
il. \___ # 2 (OS)
Ref. Ink Form Socket Assy.

# 3 (OS)

TOWERS
DISTRIBUTOR I TRANSFER BRACKETS & INK FORM SOCKET ASSEMBLIES (OS)
Index Part
1 102546 SCREW .............. .............................. ................ ....................................................... ....................... 2

2 186126 BRACKET · Distributor Roller ...... ..... .... ..... ....... ... ..... ..... .................... ............................................ 1
3 186135 BRACKET · Transfer Roller ............... .... ............................................. ............................................ 1
4 186722 WASHER - Thrust .............. .............. ..... ..... .... .............................................. ............... .................... 2
5 102428 WASHER - Spring, 1.17 i.d. ....................... .......................... ........................................................... 1
6 001070 RING - Retaining .............. ............................. ... ... ......... ................................................................. . 2
7 186721 WASHER - Thrust ................................................ ........................................................................... 1
8 186128 COVER ADJUSTER ASSEMBLY ... .... ..... ...... .. ........ ......................... ......... ............. ....................... 4
9 102585 CAP SCREW - Black, 1/4-20 x 5/8" ................ .......... .......... ...... ...................................................... 1
10 001726 WASHER ............. ..... ........................................... ........................................................................... 3
11 102228 SET SCREW - 1/4-28 .... ............................. ............... ........... .................................... .... .... ............... 1
12 102586 SCREW · Black, 1/4·20 x 3/4" ......................................... ......................................... .. ..................... 2
13 102173 SET SCREW- 1/4-28 ............................ .......... ...... .......................................................................... 2
14 186726 PLATE COVER- Retaining .......... ..... ......................... .... ...... ........................................ ................... 1
15 100185 SCREW · Nylok ................................ .... ........................... ..... ......... ..... .......................... ................... 1
16 186151 PIN - Eccentric .... ........... .... .............................. ................................ .................. .............................. 3
17 003578 NUT-#15 ........... .................................. ......... ... .............. .... ......................................... .... ............... 3
18 001731 WASHER - #25 ... ............................ ............... ....... .......... .................... ...................... ...................... . 3

TOWERS
14, 1 5 , 1 6 - - - - - - - - - - - - - - , . . , .
2, 3, 4, 5, 1 1 - - - - - - - " " " "
6------------~
7, 8, 9, 10 - - - -.......
\_Ref. Ink Form Socket Assy. #1 (NOS)
7, 8,9, 10 ' - - - - R e f. Ink Form Socket Assy. #2 (NOS)
" " ' - - - - - - - - - Ref. Ink Form Socket Assy. #3 (NOS)

TOWERS
DISTRIBUTOR I TRANSFER BRACKETS & INK FORM SOCKET ASSEMBLIES (NOS)
Index Part
1 102546 SCREW - Shoulder 5/16-18 ............. .... ........... ......................................................... ....................... 2

2 186128 COVER - Adjuster Assembly ............ ................. .. ...... .................. ...... .......... .... ............................... 4
3 102228 SET SCREW- 1/4-28 ......... ................... .......... ...... .............................. ............................................ 2
4 102586 SCREW - Black, 1/4-20 x 3/4" ............... ..... .... ...... ........... ............................. ................................... 2
5 001726 WASHER ....................... ............................................. ......... ................ ......... ..... ............... ............... 3
6 186126 BRACKET - Distributor Roller ......................................... .... ........... ................................... .............. 1
7 186722 WASHER -Thrust (1 .50) .................................................................................................. ............... 4
8 102428 WASHER- Spring, 1.17 i.d........................ ..................... ................................... ............. ................ 3
9 001070 RING - Retaining ................... ............... ......... ... ... ..... .... ..... ......................................... .................... 3
10 186721 WASHER - Thrust (2.25) ................................ ................................................................................. 2
11 102173 SET SCREW - 1/4-28 .... ............... .... .......... .......................... .......... .............. ................ .... ............... 2
12 102585 CAP SCREW- Black, 1/4-20 x 5/8" .. .................................. ............................................................ 1
13 186138 BRACKET- Mach. Transfer Roller (N.O.S.) .... ...... .......... .................................. ................ .............. 1
14 186151 PIN - Eccentric Stop ....................... ...... ........... ..... ..... ........... ......... ............... ............ .. ...... ............... 3
15 003578 HEX NUT ............ ........... ................... ..... ..................... .............. ..... ........... ..... ......... ........... .............. 3
16 001731 LOCKWASHER ................................................................ .............. .................................. ............... 3
17 186726 COVER - Retaining Plate ... .............. .......... .... ............ ..... ..... ......... .................................... .............. 1
18 100185 SCREW - Nylok .. .............................. .................... ..... ........... ........................ ................ ................... 1

TOWERS
8 ----
11 --
12 - - - -
15 - - - -
2----:--------
14

TOWERS
IDLER GEAR AND OSCILLATOR BUSHINGS
Index Part
1 186773 BUSHING · Ink Oscill ator (O.S. & N.O.S.) ............. .............. ................ ............................ ................ 6
2 102586 SCREW · Black, 1\4·20 x 3/4" .................... .... ..................... .................... .............. ......................... 16
3 186772 BUSHING- Oscillator Dampener, O.S . ................ .......... ..... ..................................... .. ..................... 1
4 186774 BUSHING - Oscillator Dampener, N.O.S......... ................................................... ....... .. ..................... 1
5 186673 SPRING- Anchor ............................................................. .... ..... ............... ..... .... ............................... 1
6 186672 SPRING- Anchor ...... ................................................. .......... ..... .................... .... ............................... 1
7 102405 SCREW - Hex Flange, 1/4-20 x 1/2" ......................... ........................ .......... ............. .. ..................... 1
8 191384 WASHER .................. ...................... ...... ............ ... ..... ..... .... .......... ...... .......... .... ............... ................ 1
9 186058 GEAR- Step Down Idler ............................................................................... ................................... 1
10 195236 BEARING .................. ........ ............... .... ...................... ..... .... ................ ............................. ................ 2
11 197048 WASHER· Wave ...... ...................................... ................ ..... .... ......................... ........ .. ..................... 1
12 186056 STUD - Idler Gear ...... ............. ......................... ...... .............................. ..... ..... .... ............................... 2
13 186843 PLUG- Plastic .... .... ........... .................... ..... ..... ..... ................ ........................ .................................. 16
14 150088 NUT .. .......................................................... ......... ................ ..... ................... ..... ....... .. ..................... 2
15 179815 BARB ................. ..... ........................................ .. ............. ..... ............... .......... ............ ... .... ................ 8

TOWERS
1 ----------,.
10, 11 , 12 - -.
N.O.S.
Frame

TOWERS
INK DUCTOR SOLENOID AND LATCH ASSEMBLY (NOS)

Index Part
1 102266 SCREW- 6-32 X 1/4" ................. ....................................................... .............................................. 2

2 186107 STUD - Pivot .................................... ..... ............................................................................... ............ 1
3 186106 LATCH ASSY. - Ink, Locout ............ .................... .................................... .......... .............................. 1
4 001080 RING - Retaining ............................................................................................................................ 1
5 190713 PIN ............................................................ ............................... ......... ............................... .............. 1
6 014515 RING - Plastic .................... ........................................................ ...................................................... 2
7 253381 SOLENOID ............... .......................................................................... .......... .................................. . 1
8 192204 SPRING ........................................... .................................... ............................................................ 1
9 192206 WASHER ....................... ............................................. ..... ......... ......................... .............................. 2
10 106108 BRACKET - Ink, Locknut .... ............................................................................... .............................. 1
11 102405 SCREW - Hex Flange, 1/4 -20 x 1/2" .............. ................................................................................ 2
12 005071 WASHER ............................................... ......................................................................................... 2

TOWERS
N.O.S. Frame

TOWERS
CAM SHAFT ASSEMBLY
Index Part
1 196997 WASHER -Thrust ........................................................................................................................... 2

2 102341 SCREW- 5-16-18 X 3 1/2" ................................ ............................................................................. 2
3 186040 SUPPORT ASSEMBLY ................... ................................................................................................ 1
4 186023 CAM SHAFT ASSEMBLY ............................................................................................................... 1
5 102108 PIN - Taper ........ ........................................................ ........... .............. ............................................. 1

TOWERS
20 - - - - - - -
6 ---------.
5-------

TOWERS
THROW-OFF CAM ASSEMBLY
Index Part
1 187104 DRIVE ASSEMBLY - Nile Latch ...................................................................................................... 1

2 100576 RING· Rataining ............................................................................................................................. 1
3 187102 LINK ASSEMBLY- Nite Latch ......................................................................................................... 1
4 001046 RING - Retaining ............... ..... .... ..................................................................................................... 1
5 186184 LINK - Tie-Ink On/Off ........ .................... ............. ........ ..... ............... .............. ............. .. ..... ................ 1
6 001047 RING- Snap ....................... ................ .......................... ......... ........................................ ..... .............. 1
7 186741 SHAFT ASSEMBLY - Ink On/Off ............ ................................................................... ....................... 1
8 187959 SHAFT ASSEMBLY - Ink On/Off (Upper) .... .............................................................. .. ..................... 1
SA 187955 SHAFT - Ink On/Off (Upper) .......... ...... ..... .... ................. ................................................................ 1
8B 186738 LEVER ASSEMBLY· Ink ON/OFF (Main) .... .................... .............................. ................ .............. 1
8C 186187 CAM- ON/OFF, Nit e Latch, Mach.29 .......... .. .......................................... ............... .................... . 2
9 187107 BLOCK - Shaft Support ..................................... .............. .... ........................ ............. ....................... 2
10 101483 SCREW -1 -1/4-20 x 1-1/4" .............................................................................................................. 4
11 197544 SPRING- Extension (Heavy) ................................................ ........................................................... 2
12 186944 SPRING STUD ........ ........................................................................................................................ 1
13 186179 SOLENOID- Air ........ ....................... ........... ................... ..... ...... ...................................................... 1
14 014472 SNRING#25 .................... ......................... .... ........... ..... ........... ...................................................... 1
15 186176 BLOCK - Base Pivot (J-Link) .................. ..... ........................................ ..................... ..... ................... 1
16 186177 LINK- Ink ON/OFF Swing (J-Link) .................... ................................................. ............................. . 1
17 187958 STANDOFF - Ink/AirCylinderPivot ................................................................................................ . 1
18 186027 STUD - Ink ON/OFF .................................... ..... .. .. ..................... .................................. .................... 1
19 197451 TRACK ROLLER- .875 .......... ................................ .... .... ................................................................. . 1
20 102256 E-RING- Bowed ........ ....................................... ...... .... .......... ............................................................ 1
21 197452 WASHER ................................... ........... ............ ........ ..... .............................. ................................... 1
22 102216 NUT - Zinc, 7-16x20 .................................................................................. ..................... ............... 1
23 102440 SCREW- Shoulder, Hex Head, 3-6 x 16 ......................................................................................... 1

TOWERS
9--------------~
11 - - - - - - - - -
10 --------.....
O.S. Frame
6 ------....
'--------- 12

TOWERS
IDLER GEAR ASSEMBLY (OS)
Index Part
1 102303 SCREW- Hex Flange, 1/4-20 x 314" 2

· · o o · · · · · · · · oo •oo · · · o o · o o · · · · · o o · · · oo· · · · · oo •oo • • o o o o · · · · · · o o · · · · oo · · · · · • • oooo • o o · · · · · · · · · · · · · ·
2 102405 SCREW- Hex Flange, 1/4-20 x 3/4" .................... ............................. ................ .............................. 2
3 191384 WASHER .............................................. ....................................... ............................ ....................... 2
4 195236 BEARING ............ ...... ........ ............... .... ......................................... ............................... .................... 4
5 186055 GEAR - Oscillator Idler .......................... ...... ............... .... ...... .............. .......... ............ ....................... 1
6 197048 WASHER · Wave .. oo • • oooooooo ooo ooooooo oo ooo oo oooooooooooo . . . .oo oo oo• 2
000000 00 0000000 oooo • •oooooooooooo oo ooooooooo • oo· 00 00 000 00 0000 00 00 0000 • •
7 186058 GEAR -Step Down Idler (Mach) 1

0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . 0000 00 00 00 00 00 00
8 150088 LOCKNUT- 2
•oo oo oo oo oooo • • •oo oo oo • • oo.oooo• oo• oo oo oo• oo •oo· · . . . . oo oooooo oooo oo oo oo . . . . oooooooooo o oooo • oo•oo• ooooo oo oo oo• • • ooooooo oooo oo oo• oo• oo ·
9 186673 ANCHOR - Spring 00 000 . . oo • • 00 • • oo. 00 . . oo 00 00 • • oo 00 00 .oo 00 00 00 . oo. 1

0000. 000 00 00 00 00 00 .oo . 00.00 oo . 00 oo . 00 00.00 0000 . . oo . . 00.00 00 00 00 00 00 00 00 00 00
10 186056 STUD- Idler Gear . 0000 0 0000 00 00 0000.0000.000000 0000. 00 00.00 00 oo · oo· 2
00 0000 0000.0000 0000 0000.00000 . 0000.0000.0000 0000 . oo • • 00 00 00 . 0 0 00 oo. 00 00. 00 .
11 186672 ANCHOR - Spring 00 000 0 0000 . oo • • oo. 00 0000 oo oo• 000 00 oooo• oo . . . . .oo. oooo• 1
000 00 00 00 00 oooo• . oo . oooo • oooo• oooo• 000000 oooo• . . . . 00 00 0000 00 00 00 00 00 00
12 186050 MAI N DRIVE ASSEMBLY 1

•ooooooooooooooo oo ooooooooo . . . . . . .. . . ooooooooo• oo •oo•oooooo oo ooooooooooooooo . . . oo oo oo • o o · · · oo . . . oooo oo oo oooo oo • ·

TOWERS
9 --------------~
4- - - - - - - - - - - - - -
O.S.
5- - - - - - - - - -
2-----
11 - - - - - -J....-- NOS Frame

TOWERS
TOWER FRAME BUSHINGS AND BRACES
Index Part
1 102240 BUSHING- Sleeve, .721 ................................................................................................................. 1

2 102464 BUSHING- Sleeve .752 x .878 x 1.0 ............................................................................................ 2
3 102508 BUSHING- .5015 X .628 X .75 ········································································································ 2
4 102064 SCREW - Socket Head, 3/8-16 ....................................................................................................... 8
5 102441 PIN - Dowel, 1.26/ 1.24 Ground ............ .......... .................................... ............................................. 2
6 102036 RETAINING RING- 2-7/16 ............................. ............................................................ ..................... 2
7 187310 INK FOUNTAIN ROLLER & BLADE ASSEMBLY .......................................................................... 1
8 186005 BRACE - Ink Tower ....... ................... .......... ..................................................................................... 2
9 102441 PIN - Dowel, 1.26/ 1.24 Ground ........ .... .......... ........................... ...................................................... 1
10 001425 BUSHING - Oilite ............................................................................................................................. 1
11 102463 BUSHING - .5015 x .628 x .75 ........ ................................................................................................ 4
12 102464 BUSHING- .752 x .878 x 1.0 .......................................................................................................... 1

TOWERS
2
.........
' '\. \
Tower #2 \ ( Tower #1
,....---,-------,\
\ I
\ \. /
/
" /
0
/
/
0
/
/
/
1 ./
/ 4
..... .....
./
3
4 5

TOWERS
ATTACHING THE BASE, MID AND TOWERS
Index Part
1 102581 SCREW- Mach., Black, 318-16 x 1 1/2" .......................................................................................... 8

2 102566 SCREW - Mach., Black, 3/8 -16 x 1 1/4" ........................................................................................ 4
3 101756 SCREW ........................................................................................................................................... 4
4 102566 SCREW- Mach. , Black, 3/8-16 x 1 1/4" .......................................................................................... 6
5 186488 PIN ............................................................ .... ........... ......................... ............... .............................. 2
6 186487 PIN ................... ................ .............. ............... ............................... ............... ................ ................... 2

TOWERS

TOWERS
CLEAN-UP TROUGH
Index Part
1 186207 PLATE · Blade Backing ................... ..... ...... .... .. ...........................o···o·············oo········ ·o····o···········o···· 1
2 180858 BLADE · Clean-Up .. oo... oo• ..o.. o..oo....... ... o.o. o• o.. oo...
000. 000. 0 • • • • • 0 00 • • •oo.0 0 0 00. 0 • oo . ooo.. o•. o..... o.
• 000 • • 0 0 • • ••••••••• 0 000. 000 1
3 186213 TUBE - Plunger, Ink Clean-up oo ooooo·· ·······o········· ooo····· ········o··········o···o·············ooo······· ······o··············o· 1
4 186212 PIN - Plunger, Ink Clean-up .. o......... ......oo••o····· ···o··············oo•········o·•oooo......... .. o.o•······ .o.... o.......... o... o. 2
5 111052 SCREW ···················-········································ ········· ········· ·········o····· ·········· ····· ······· ······················· 4
6 187307 BRACKET - Clean-up Pan, (NOS) .. ............... ....o........... ... o.......... o•ooo•............ oo ...... •o··· 0 0 0 0 •••• • ••• • • • ••••• 1
7 187306 BRACKET- Clean-up Pan, (OS) ··········· ·············o·············oo··········-···o·············oo············ooo················ 1
8 101333 PIN -Roll .......................................... .......................... .............................................. ........ ............... 2
9 102435 SPRING - Coil ....................... ................ ......... ...... ..................... ......... ............... .............. 0 . . . .. . . . . . . . . . . 1
10 187305 PAN -Ink, Cleanup ............................................... ............................................ ............... 0 .. .. ... .... .... 1
11 102157 SCREW - 10-32 .............................. .......... ..................... .................... ......... ............... .................... 7

OIL SYSTEM

OIL SYSTEM
0
0
27
() 25,26
7,8,9, 10
24 11 , 12, 13
23
14, 15, 16
22
17
18
0
0
19
0
20
21

OIL SYSTEM
BASE ELECTRICAL
Index Part
1 197397 TEE - Union, 3/8" o.dl. ........................ ......... ..... .................................................................. .............. 1
2 178401 TUBING - Natural, .170 i.d. x .250 o.d. (sold 22.5') ..................... ................................................... 1
3 173076 PAN - Oil Pump .............................................................................................................................. 1
4 178401 TUBING- Natural, .170 i.d. x .250 o.d. x 23" (sold 22.5") ............................ .................................. 1
5 172713 TUBING - Black, .25 i.d. x .375 o.d. x 6" (sold 7.5") ......................................... .............................. 1
6 172713 TUBING - Black, .25 i.d. x .375 o.d. x 17" (sold 7.5") ....................................... .............................. 1
7 197396 FITTING - Male Elbow ................................................................................................ .................... 1
8 172705 FILTEA - Regulator ......................... ........... ..... ......................................................... ....................... 1
9 172706 BRACKET - Regulator ............ ......... ..... ............ ................................. ............................................. 1
10 001649 SEMS UNIT ..................................................................................................................................... 2
11 001702 WASHER- .196 i.d. x .500 o.d ......... ............... ......................................................... .. ..................... 2
12 000666 WASHER - Lock, .196 i.d. x .334 o.d ................. ................ ..................................... .. ..................... 2
13 001812 NUT - Hex, 10-32 .............................................................................................................. .............. 2
14 179804 NIPPLE - Close ... ............... .............. .................................................. ............................................ . 2
15 .253383 CONNECTOR ................................... .......................... ..... ..... .............. ............... ................ .............. 1
16 196971 CONNECTOR- Male ........................................................................................ .............................. 1
17 172704 COUPLING - Block .......................................................................................................................... 1
18 179832 COCK - Drain ................................... .................................................................. ......... .................... 1
19 001649 SEMS UNIT ................................................................................................................. .................... 2
20 197395 FITTING · Male .................................................................................................................. .............. 1
21 172713 TUBING - Black, .25 i.d. x .375 o.d. x 18" (sold 7.5') ....................................... ....... .. ...... ............... 1
22 173083 GASKET- Foam Rail, 1-1/2' .. ........................................ ................................................................ 1
23 172713 TUBING - Black, .25 i.d. x .375 o.d. x 15" (sold 7.5") ....................................... ................ .............. 1
24 197395 FITTING - Male .................................................................................................. .......... ...... .............. 1
25 197416 RIVET - Snap .................................................................................................................................. 2
26 .250098 CLAMP - Cable .................................................................................................. .............................. 2
27 172713 TUBING - Black, .25 i.d. x .375 o.d. x 30" (sold 7.5") ....................................... ....... ....................... 1

OIL SYSTEM
(OS)
17
8
\
\
\ I
2
8 I
'
1
I
I
11 10
12
16 -" ~---- /
...........
14- - - - - - - - - -

OIL SYSTEM
LUBRICATION SYSTEM (OS)
Index Part
1 102303 SCREW - Hex Flange, 1/4-20 x 314" ........................................................... ................................... 4

2 173173 PLUG - Closure .......................................... ....................................... ............................................. 2
3 187166 JUNCTION - 6-Way Single ..... ..... ........ ........................................................................................... 2
4 150084 NUT - Hex ....... ............................. .................... ............................................................................... 4
5 186923 STANDOFF - Switch Bracket ........................................................ .... ..................... ........................ 4
6 186920 BRACKET- Tower Switches ........................................................ ............... ................................... 2
7 187274 TUBING .......................................................................................................................... AS REQUIRED
8 178404 TUBING ............................................ ................................... ........ ................. .................. AS REQUIRED
9 253918 SWITCH - Pressure .............................. ............................... ..... ..... .................... ..... ........................ 1
10 180482 JUNCTION - 4-Way ......................................... ................................................................ ............... 1
11 180494 BUSHING - Compression, 5/32 ... ..... ................................................................. ......... .................... 6
12 180497 SLEEVE - Compression, 5/32 .......... ............................................................................... ............... 6
13 102545 NUT - Compression ....................................................................... ................................................. 8
14 187301 FERRULE ........ .............. .... ........... .... ............................................ ................ ..... ......... .................... 8
15 187167 MET ER - Unit, FJB-0 ........................ .... ..... ...... .... ......... ................ .............................. .... ............... 8
16 186433 BARB ........................................................................................... ...... ......................... .................... 8
17 250077 STA-STRAP ................................. .... .............................................. ............................ ..... ............... 2

OIL SYSTEM
~ _.r----19
OIL ~SERV.

OIL SYSTEM
LUBRICATION SYSTEM (NOS)
Index Part
1 187162 BRACKET - Angle Junction oo ..... oo ..... ............... ................... ...... .... •..........................•.•..................... 2
2 102572 SCREW- Hex Flange, 1/4·20 x 1" ........................ ........................ ..... ............... .................. ............ 4
3 021203 WASHER .............................................. ......... .............................. ............................ ....................... 8
4 150084 NUT - Hex ........... ................... ................ ..... ..... .............................................. .................................. 4
5 187163 JUNCTION - S-Way ... ....................... ..... ............................................................ ....... ....................... 2
6 187274 TUBING .............................. ............... ............................................. ................ .................. AS REQUIR ED
7 180479 JUNCTION-6-WayDouble ............................................................................................................. 1
8 180494 BUSHING - Compression, 5/32 ................... .......oo.oooo•••oo••oo··· oo···oo··· oooo•oo········oo···oo·····•oooo•oooo·········oo· 6
9 180497 SLEEVE - Compression, 5/32 oo..... oooo ooo .. oo oo· ··oo oo.oo .. oo ... oo.oooo .. oooo·· ··oo·oo·•oooooo•·oo··········oo .oo.oo .. oooo·······oooo 6
10 178404 TUBING ..................... ............ 00 • • • • • • • • • • • • • • • • • • • • • • • • • • • • AS REQUIRED
• • • • • • • • • • • • • • • • • • • • • • 00 • • • • • • • • •••••••••••••• • •• ••••••••••• •
11 180494 BUSHING-Compression, 5/32 oo············oo··· oo oo ...... oooo············ oo········ ·····oo·············oo············oooo········oo· 1

12 180497 SLEEVE - Compression, 5/32 ........... .............. ..................... 00 . . . . . . . . . . . . . 1 .......... .. .. . . . . .. . . .. .... . .... .. .. ... .....
13 180500 ADAPTOR · 90 Degree Elbow .... oo....... ...... oo ............. oo ...•.....

00 00 . . . ... . . . 00. oo .•....................... 2 00 • • 00 • ••••••• • •• •
14 180494 BUSHING-Compression, 5/32 oo············oo·••oooo ........ oo······· ····· oo········ ·····oo········ ····························oo••oo 1
15 180497 SLEEVE- Compression, 5/32 oooo•••oooo oo•·· oo ....... ............ ......... ............... oooo .................. ........ 1 00 . . . . . . . . . . . . .
16 178404 TUBING ...oooo·············· ································· 00 . .. . oo········ ·oo·························· AS REQUIR ED

. .. . . . . 00 • • • • • • • • • • • • • • • •
17 180478 FILTER ASSEMBLY ······oo· ···oooooo······· ··oo·oo· oo··· ······ oo············oooo• oo• .................
0 0 . . . . . . .. . . . 0 0 • • • • • • • • • • • • • • • • 1 000000
18 180508 FILTER ELEMENT- Replacement ····oo·oo·· oo... .. oo oooo .. oo ...... oo oooo•oo········· oo···oo··· .. ···oooooo .... ..... oo ......... oooo. 1
19 180477 LUBRICATOR-One liter ........................... oo oo· ·········oo·············oooo··················oo·oo······ oo····················· 1
20 180492 NUT· Compression, 1/8 ...... oo .oo.. oo...... oo .. oo ... oooo· ..... oo ......•.... oooo ........... oo oo· oo ........ oooo····· ...... 12
0000 • • • • • • • • • • • •
21 197312 FERRULE ··························oo·oo······ ···· oo oo .. oo ......... ................................. .............. ....... ...................... 12

22 187167 METER ·Unit, FJB·O ........ oooo oooo .. ooooooooo• oo••oooo .. ...oo.oooo···oo oo oo···oo·· oooo •. oo.oooo·· ··oo·oo···oooooo····oo···oo·····oo•oooo 12
23 173173 PLUG- Closure .... oooo· ··············oo·········oo·············.. ··oo·············oo··oo·········oo············oooo•oo·········oo·· oo·······oo 2
24 186433 BARB .... oo .......... oo .. oo . ...... oo.oo•oo•oo• oo····oooo•oo······oo••oo•oo············ ·oo·· oo··· ······ ····oo···· .. oo•oooo ... ........ oo ......... oo .. 6
25 173173 PLUG - Closure oooo· ··· .oo.0000 oooo .. oo• oo· .oo .. oo ... .. oo ...... oo ..... oooo .... oo ..... oo •..... oo ...... oo oo ..
00000 oo. oo. oo ....... oo .. 4 0000 . 00 00. 00
26 254867 ANCHOR- Wire Tie ·· oo·····oo··oo··oo···························oo·oo········· oo············oo·············oooo···· ·······oo············oo 2

27 250077 STA.-STRAP ...... oo.oooo. ........ ooooooooo····ooooooooo .... ... oo.ooooooo····oooo··· oo············ oooo•oo·oo······ oo··oo· ···oooo oooo········oo· 10

MIDSECTION
Century3500 Parts Catalog 5-1

MID SECTION
13
1, 2
5-2 Century3500 Parts Catalog

MID SECTION
ANTI-SCUFF UNIT
Index Part
1 186929 GUARD · Impression Cylinder Edge, nos ....... ........ .................... ........................... ........... ............ 1
2 186930 GUARD · Impression Cylinder Edge, os ... ........................................... ........... .......... .................... 1
3 186931 BRACKET - Sensor Support, nos ... .... .......... .............................. ................................................... 1
4 186932 BRACKET - Sensor Support, os ... ...... ......................................... ................ ................................... 1
5 187152 GUARD - Scuff Segment 1 .............. ..... .... ........ ........ .... ................ .................................................. 1
6 187151 GUARD -Anti-scuff Segment 2 ........ .................... .......... ...... .... ..... .................................................. 1
7 187150 BRACKET - Sensor Connector ................................ .......... ..... ......... .............................................. 1
8 186942 BUMPER - Guards ........... ..... ..................... ............... ...... .... .... ................ ..... .... .............................. . 2
9 014219 SCREW - Socket Head, 1/4-20 x 3/4" .. ..................... ..... ..... ..... ......... .............................................. 2
10 014808 NUT - Keps, 10-32 ........... ..... ........... ..... .................................................. ..... ................................... 4
11 100625 SCREW - Cap, 1/4-20 x 1/2" ..... ........... .... .......... ...... ..... .... ..... ................ .... ................................... 10
12 101299 SCREW- 4-40 X 1/2" ........ ..... ............... ..................... ..... .... ..... ..................... .... ........ ....................... 1
13 178186 DET ECTOR - Blanket ........ .... ............... ............... ............................. ........... ................................... 1

MID SECTION
15 ------..
~--- 26
1 ------....
14
13
11 ----::==~
1 0 ----+--;-----;.L
9 ----ti---6&1
~:J---!j.---l:lti:::f----rl _r--18,
19
---- 24
Jlljjji!~...,\1-\"I-\1-\1-\"I-\\-\1-\"I-\1-\\-\J...:..t-~
22
23 - - '
View for Tower 1

MID SECTION
PLATE AND PAPER ADJUSTMENT- PART 1
Index Part
1 186825 PANEL- Fixed ... ....... ....... ................. .............. .......................................................... ....................... 2
2 186388 DIAL ASSEMBLY- Paper Thickness (Tower 2) ................................ ...... ..... .................................. 1
3 186387 DIAL ASSEMBLY - Paper Thickness (Tower 1) ............................................................................. 1
4 100352 SCREW - Set ...... .............. ............... ............... .. .......................................... ............... ..................... 2
5 186384 DIAL ASSEMBLY - Plate (Tower 2) .. ..... ..... ........... ..... ............... ......... ..... ........................................ 1
6 186383 DIAL ASSEMBLY- Plate (Tower 1) .. ..... ..... ........... ..... ............... .............. ........................................ 1
7 102157 SCREW - 10-32 ........ ............................. ......... ...... ..... ........... ..... ......... .......... ..... .............................. 1
8 186833 DETENT ......................................................... ........... ..... ...... ..... .... ..... .......... ..... .............................. 1
9 100352 SCREW - Set .......................... ............. ............. ... ..... ............... ..... ..... ......... ..... ............................... 1
10 019238 NUT .......................... .................................. ..... .... ................ ..... ................... ................................... 1
11 193090 WASHER- #12 ................. .............................. ......... ..... ..... ...... .... ..... ............... ......... ...................... 1
12 186832 POINT ER - Plate Th ~ckness ............ ...... ........ ............ ..... .... .................... ..... .... ............................... 1
13 017462 SCREW - Pivot ......... ............. ........... ................... .............. ..................... .... ..... ............................... 2
14 186098 KNOB - Straight Knurled ... ............... .............. ........... ..... .... ................ ..... ........................................ 2
15 101743 SCREW- 1/4-20 X 1/2 " ..................... .................... ..... ................... ...... ..... ..... .... ........ .. ..................... 8
16 186834 SHAFT AND CAM ASSEMBLY (Tower 1) ........ ............... ..... ............... .......... ................................... 1
17 186835 SHAFT AND CAM ASSEMBLY (Tower 2) ... .......... ..... ..... ..... ...... .... ..... ............................................. 1
18 186845 SHAFT AND CAM ASSEMBLY - Paper Adjust (Tower 1) ... .... ............ .... .......... ....... ....................... 1
19 186844 SHAFT AND CAM ASSEMBLY- Paper Adjust (T ower 2) ............. ............... ................................... 1
20 014799 WASHER .............................................. ..................... .................... ..... ..... ..... .... ............................... 2
21 186828 STANDOFF - Plate ........................... .... .......... .. ... ..... .... ................ ..... ..... .... ..... ............................... 2
22 102064 SCREW - Socket Head ......... ........... ..... ........ ............ ..... ..... .... ................ ..... ..... .............................. 2
23 101756 SCREW .................... ....................................... .......... .......... ...... ......... ..... ..... ................................... 4
24 186845 SHAFT AND CAM ASSEMBLY - Paper Adjust ........ .... .......... .... ..... .................... ....... ....................... 2
25 197498 SPRING - Compression ....... ................ ..... .......... ..... ..... ...... .... ..... .......... .......... .............................. 2
26 186654 STANDOFF ...................................................................................................... ............................... 3

MID SECTION
~/~\____
~ 1J" 16
r 6.7 17
/~

MID SECTION
Index Part
1 186832 POl NTER - Plate Th k.................................................................................................................... 1

2 186383 DIAL ASSEMBLY - Plate (T1) ...... .... .......... ........... ......... ...... ................... ..... ...... ...... ... .................... 1
3 186384 DIAL ASSEMBLY - Plate (T2) .................... ........... .......................................................................... 1
4 019238 NUT .................... .............................................................................................. ....... ........... ............ 1
5 193090 WASHER - #12 ................................................................ .......................... .... ........ .. ..................... 1
6 186834 SHAFT - Cam Assy. (T1) ...... .................... .............. ...................................................................... 1
7 186835 SHAFT - Cam Assy. (T2) .................... ........................................ .................... .............................. 1
8 186826 PLAT E - Lateral Adjust ...................................................... ..................................... .. ..................... 1
9 186833 DETENT ............................. ........................ .................... ............... .................................................. 1
10 102157 SCREW - 10-32 .............. ............................................ .............................. .................................... 4
11 130033 SETSCREW ...................... ......................... ..... ..................... .............. ............................................. 2
12 072411 PIN - Spring ......................................... ......... ............ ......... ......................... ............ ....................... 1
13 071181 SCREW · Shoulder .................................................... ............... ............... ............... ..................... 1
14 073078 LATCH & PIN ASSEMBLY .............................. ................................................... .............................. 1
15 197024 PLUNGER - Ball .................................. ............................................. .......................... .... ............... 1
16 197025 SCREW - Shoulder ..................................... ... ........................... ........... .... .......... .......................... 2
17 179172 RATCHET- Stop ... ........... .................................. .................................................. ... ....................... 1

MID SECTION

MID SECTION
Index Part
1 017462 SCREW - Pivot ............................... ............................................................................................... 1

2 180385 SHAFT ASSEMBLY ............... ..... .............................................. ......... .......... .................................... 1
3 192798 WASHER ............................... ............... ........................................................................................... 1
4 014158 SCREW ........ ..... ............................................................................................... ..... .. ....................... 3
5 186098 KNOB - Straight, Knurled ............................................................... .......... ............. .. ..................... 1
6 186099 INDICATOR, Position (6:1) ............................................................................... .............................. 1

MID SECTION
()
()
C)
~ ()
()
()
C)() ()
()
C)

MID SECTION
Index Part
1 102568 SETSCREW Nylok, Black, 5/16-18 ................. .......... ..... ................................................................. 2

2 179167 GEAR - 50 Teeth ............. ..... .......... ...... ..... .... .......................... ............... ..... ................................... 1
3 014158 SCREW ................................. ................ ................... ................ ..... .......................... ........... ............ 3
4 186098 KNOB · Straight, Knurled ............... ........................ .................... ........................... ....................... 1
5 186099 INDICATOR - Position (6:1) ....... ........ ...... ............... ..... ................................................................. 1
6 017462 SCREW · Pivot .................................... .............. ..... ........... .... ................ ........................................ 1
7 180384 SHAFT ASSEMBLY ........... .............................. .... ................ .......... .............. ................ ................... . 1
8 178995 HOUSING - Shaft ......................................... ........... .... ............................... ................................... 1

MID SECTION
~----- 1
___.....,. .----- 2
~- 4

MID SECTION
Index Part
1 102539 PIN - Driv. Lok. Type G1 1/2" ......................................................................................................... 1

2 001978 PIN - Roll .......... .............................. .......... ..... ............................................ ............... .... .. .............. 2
3 101854 BUSHING - Flanged ...................................................................................................................... 3
4 186826 PLATE - Lateral Adjust .................................................................................... .............................. 1
5 014618 BUSHING - Flanged ........................................................... ........................ ................................... 1
6 101854 BUSHING - Flanged ........ ..... .................................................. ............... ........................................ 1

MID SECTION
6 ------....
13 ---.....
1 0 ------....._

MID SECTION
Index Part
1 186845 SHAFT - Cam Assembly (T1) .......................... ............................................................................. 1

2 186844 SHAFT - Cam Assembly (T2) ......... .... ........................................................... .... .......... ................. 1
3 197498 SRING - Compression ........................ .......... ......................................................... ........... ............ 1
4 014799 WASHER .......................... ............................................................................................................... 1
5 014576 PIN - Driv. Lok. ................. ................................................................ .......... ................................... 1
6 186826 PLATE - Lateral Adj . ...................................................................................................................... 1
7 186098 KNOB - Straight, Knurled ......................................................................... ...... .............. ................ 1
8 017462 SCREW - Pivot .............................................................................................................. ................ 1
9 102157 SCREW - 10-32 .............. .............................................................................................. ................ 2
10 186832 POINTER - Plate Thk....... ............................... .......................................... .................................... 1
11 130033 SETSCREW ............................................... ........................................ ............................. ................ 2
12 102157 SCREW - 10-32 ............................................................................... ......... ............... ..................... 2
13 186833 DETENT ......................................................... ........................... ................... ................................... 1
14 186387 DIAL ASSEMBLY - Paper Thickness (T1) ...................................................... .............. ................ 1
15 186388 DIAL ASSEMBLY - Paper Thickness (T2) ...................................................... ....... ....................... 1
Century3500 Parts Catalog 5-1 5

MID SECTION

MID SECTION
Index Part
1 102533 KEY · Woodruff, 3/32 x 5/16 302.5 ................................................................................................ 2

2 100554 PIN - Spiral ....... ................ .... ............... ........................................ .......... ..... ............... .... ................ 2
3 179166 GEAR - 40 Teeth .................. .......................................................................................................... 2
4 186866 SHAFT - Intermediate Fine Cir. .................................................................................................... 2
5 197076 WASHER - Thrust ........................................................................... .............. ................................ 2
6 102256 E-RING · Bowed, Zinc .660 .......................... ........................................ ........................................ 2
7 179156 GEAR ................................ ............................................................................................................... 2
8 102568 SETSCREW- Nylok, Black, 5/16-18 ................................... ..................................... .. ..................... 2

MID SECTION
15----...
17
18
16
Side View

MID SECTION
PULL GUIDE SPROCKET DRIVE ASSEMBLY
Index Part
No. No. Description Quanltity
1 401352 PULLEY - Idler ·········-································································ ........... ..................... ....................... 1

2 102581 SCREW - Mach., 3/8-16 x 1-1 /2" .................... ...... ........................................................................... 3
3 150088 NUT- Lock ··············-································ ...... ....................................................... ·-······················· 3
4 102574 SCREW- Hex Flange, 1/4-20 x 1 3/4" ·· ··········· ··· ·························-···· ················ ······· ······················· 3
5 005071 WASHER ·················-································ ..... .......................................... .............. ··-······················· 3
6 102300 SCREW - 1/4-20 ...... -......... .................... ..... ............... ................... -............... ................................... 3
7 014788 WASHER ·················-······················· ········· ................. ......................... .............. ....... -.. ..................... 3
8 186355 SPROCKET ............ ·-··· ...... ................... ....................................................... ................................... 1
9 186298 PULLEY - Timing .... -......... .................... ......... ..................... .......... ............... ................................... 1
10 186354 HUB - Sprockets ·····-····· .. ························· ..... .................... .............................. ....... -....................... 1
11 186299 BELT - Timing ·········-····· ........................ .............................. .... ............... ........................................ 1
12 186288 STANDOFF -Idler ····-········· ··············· ····· ·························· ····· ········· ··············· ··································· 2
13 102303 SCREW- Hex Flange, 1/4-20 x 3/4" ................................................................................................ 2
14 005071 WASHER ·················-······················· ····· ···· ................................................... ........... -.. ..................... 2
15 186289 BRACKET - Idler ····· ·-········ ····· ········· ······ ············ ........ ............................................... ....................... 1
16 174017 SCREW - Shoulder ·-························ ··············· ..········ .......... ..................................... ....................... 1
17 014372 SETSCREW .......... ··-···· ........................................................ ........................................................... 1
18 173810 DIAL - Engraved ······-····· ........ .......... ..... ..................................... .... ............... ................................... 1

MID SECTION
16 --------. 1, 2
15- -.. . . . 3
-----4
_,.---5
------- 6
~~~-- 7
~:>=------- 8
~----- 9
Pull Guide Drive Assembly

(Viewed at N.O.S")
24
r ·24 r 25
:f- I
'io.
------- -----
Jl
;r.
7
'/ ~
?<(A.;"'"'-'
" ~
LlLJ-J~ - -
I
., £~
I
el
14
13
12
~
-·
--------------------
......., - - ·0 10
~
[If
~. Ll y ~ R I ID 11
~
I I
• -@
..
(
~·
'' '
'-21 '- 17, 18

- 22 19
- 23 20
24 - - - - - - . . . . 26
33 -----......._ 27
36-----~~~~~ 28
35 ---------.. 24
3 4 - - - - --....
Vacuum Valve Assemblv

MID SECTION
PULL GUIDE DRIVE AND VACUUM ASSEMBLY
Index Part
1 102313 ROLLER - Track Crowned .... .......... ...... ........... .. ........... ..... .... ................ ..... .... ............................... 1
2 101051 NUT ................................... .... .......................... .... ........................................................................... 1
3 186290 LEVER ASSEMBLY- Vacuum .................... .... ...... .................... .......... ......... ..... ................ ............... 1
4 197293 POST - Spring Anchor ....................................... ............................................................................. 1
5 065402 SPRING - Extension .......... ..... .................... ............................................. ....................................... . 1
6 186295 BRACKET - Spring Anchor ............................................................................................. ................ 1
7 102405 SCREW · Flange, 1/4-20 x 1/2' ...................................................................................... ................ 1
8 014195 SCREW - Cap ................... .... .......................... ................................................................................ 2
9 186293 BLOCK ASSEMBLY- Pivot ..... ........... .... .... ........... ................ .... ..... ..... .......... ............... .................... 1
10 197353 ROD ENDS - Female, R.H . ................................... .... .......................... .... ........................................ 2
11 001834 NUT - Hex ........... ............... ...... ..... .... ..................... .... .......... ........... .... .......... ................................... 2
12 186281 ROD - Connecting ............. .... ................ .......................................................................................... 2
13 102215 NUT - Hex, 5/16-24 .............................. ...... ............... .............................. ........................................ 2
14 197354 ROD ENDS - Female, L.H ..... .......................... .... .... ........................................ ......... .................... . 2
15 001755 WASHER ............ .............. ..... .......... ..... ................ ..... ..... .... ........... ..... .......... ................................... 1
16 001080 RING - Retaining .............. ..... ............................... ..... .......... ............................. ........ ...................... . 1
17 102571 SCREW · Hex Flange 5/16-18 x 1 1/4" .................... ........................ ....................... .. ..................... 1
18 150086 LOCKNUT ........ .................... .................................................................................... ...................... 1
19 014784 WASHER ............ .............. ..... .......... ..... ................ ..... ..... .... ........... ..... ..... ..... .... ........... .................... 1
20 186788 BUSHING - Long Link ...... .............................. ................................................................................. 1
21 197079 SCREW · Shoulder, 1/4·20 ............. ............................................. ..... ............................................. 2
22 001766 WASHER ............ .............. ..... .......... ..... .... ............ ..... ..... .... ................ ..... ......... ............... ................ 2
23 197080 SPRING - Compression .. ..... .... ........................... .................... ..... .......... .............. .......................... 4
24 102405 SCREW· Hex Flange, 1/4-20 x 1/2" .............. ...... .............................................. .............. ............... 10
25 186276 BRACKET ............... ........................................ .. ........ .... .......... ............... .................... ..................... 1
26 150084 NUT - 1/4·20 ...................... .... ........... .......... .... .................................................................. .............. . 2
27 186277 BODY· Valve ......................... ......................... ...... .......... ..... ......................... ............ ...................... . 1
28 186282 BRACKET- Guide .. ......... .................................... .................... ....................................................... . 1
29 186278 PLATE- Vacuum Shuttle .. ..... .......... ..... .... ........... ..... .... ..................... .... ..... .... ........... .... ................ . 1
30 186279 SUPPORT ASSEMBLY· Valve ........ ........... ..................................................................................... 1
31 186283 STANDOFF ...................... .... ...... ..... ..... ............. .. ........................ ..... .................... .......................... . 2
32 150084 NUT- 1/4-20 ...................... .... ........... .......... .... ................................................................................ . 1
33 186284 VALVEASSEMBLY - 3-Way ... ......................................................................................................... 1
34 102405 SCREW· Hex Flange, 1/4-20 x 1/2" .......... .... ...... ................ .............................. .............. ................ 2
35 014741 WASHER -Spring ............. .... ............... ..... .... ................................................................................. . 2
36 186287 BRACKET - Vacuum Control .......... ......................... .......... ........................ ...... ......... ..................... 1

MID SECTION
6
1 ,------------,
:Q'-7~16!
L ___________ j
19----" 17 -___,r

MID SECTION
PNEUMATICS- OPERATOR SIDE- PART 1
Index Part
1 172711 VALVE - 3-Way Assembly .......................................... ...... ......................................... .. ..................... 8

2 196971 CONNECTOR - Male ................................. ..... ... ...... ..... ..... .............................. .............................. 1
3 197507 TEE - Union, 1/4 o.d....................................... ................................................................................ 2
4 197506 SWIVEL- Male Branch Tee .............. .............. ......................................................... ....................... 5
5 179804 NIPPLE - Close .................................... .................................................. ........................................ 8
6 197510 UNION- Expander ........... .................... ...................................................................... .................... 1
7 178401 TUBING- Roll .170 i.d. x .250 o.d. x 500' ...... .......................... ................................ ....................... 1
8 TUBING- .170 i.d. x .250 o.d. x 11 -1/2" ... .. ............ ..... ........... .................................................. 1
9 TUBING - .170 i.d. x .250 o.d. x 2" .......... ...... ..... .... .... ................ ......................... ..................... 1
10 TUBING- .170 i.d. x .250 o.d. x 14" ..... .... .................... ............................................................ 1
11 TUBING - .170 i.d. x .250 o.d. x 7" ............................. ..... ................ .................... ..................... 1
12 TUBING - .170 i.d. X .250 o.d. X 9 -1/2" ........................ ........................ .................................... 1
13 TUBING- .170 i.d. x .250 o.d. x 13" ......................................................................................... 1
14 TUBING - .170 i.d. x .250 o.d. x 9-1 /2" ........................ ........................................ ..................... 1
15 TUBING - .170 i.d. x .250 o.d. x 5-1/2" ........................ ......... ................ ............... ..................... 1
16 172713 TUBING- Roll, Black .250 i.d. x .375 o.d. x 500' ................... ................................. ....................... 1
17 TUBING- Black, .250 i.d. x .375 o.d. x 32" ............. .... ............................................................. 1
18 TUBING - Black, .250 i.d. x .375 o.d. x 2-1/2" .... .... .............................................. .................... 1
19 197397 TEE - Union, 3/8 o.d......... ............... ............................................. .............. ..... ............................... 1
20 197510 EXPANDER - Union ........................................ .............. ...... ........................................................... 2

MID SECTION
OS
21 , 22, 23
, - - -10 33,34
26, 27, 28, 29, 36

.____ _ _ _ 24, 25

MID SECTION
PNEUMATICS- OPERATOR SIDE- PART 2
Index Part
1 186799 CYLINDER - Air ......... ....................................................................................................................... 4

2 179370 CLEVIS - Piston Rod . .............. ......................................................................................................... 4
3 178360 PIN - C levis ............... ....................................................................................................................... 4
4 186831 LEV ER- P/B Throwoff ........................................ ............................................................................. 2
5 186842 STANDOFF - Air Cylinder ....... ............... ............................................................................ .. ............ 4
6 186836 LEVER- BL. I Imp. Th rowoff .......................................................... ................ .............. .................... 4
7 186802 GUI DE- Push Rod ........................................................................................................................... 2
8 179323 ECCENTRIC ................................................................................. ............................ .. ..... ................ 2
9 186803 PUSH ROD ....................... ........................................................... ............... ............. .. .................... . 2
10 186837 LINK-P/BThrowoff ........................................................................................... ............................... 2
11 186801 HOUSINGASSEMBLY ................................... ......................... ......... ...... ................. .. ..................... 1
12 186840 PIN .. ................................. .......................................................................... ............ .. ..................... 2
13 186804 STUD - Adjusting Eccentric ............................................................................................................ 4
14 186805 LINK - Eccentric Housing .................................. ................................. ......... .................................... 4
15 102454 SCREW - Socket Head, 3/8-16 ................................................................... ............. .. ...... ............... 4
16 102064 SCREW-3/8-16x 1-1/4" ................................................................................................................. 2
17 186870 STANDOFF - Air Cylinder ............................................................................................. ................... 2
18 186840 PIN .......................... ......... .......................................................................... ................................... 4
19 001080 RING- Retaining ............... .................................................. ............... .......... ............ ....................... 8
20 197496 PIN- Dowel ...................................................................................................................................... 2
21 180208 SPACER ................... ............................................ ................ ............................ ............................... 4
22 197343 LOCKWASHER- Bearing ... ............................................................................................................ . 4
23 197344 LOCKNUT -Bearing ........... .................................. .................................................... .. ..................... 4
24 102040 SCREW- 1/4-20 X 1-1/4" .................................................................... ............................. ................ 2
25 003578 NUT - Hex ........... ............................................................................................................................. 2
26 102055 SCREW - 1/4-20 X 1/2" .............................................................................................. ..... .... ............ 4
27 193338 WASHER ........................................................................................... .......... ............ ....... .... ............ 4
28 018684 DRIVE LINK ASSEMBLY ................................................................................................................. 2
29 101281 DRIVE - Loc Pin ............................................................................................................................... 2
30 186838 LEVER· Clamping, Tower 1 ............................................................................................................. 1
31 186839 LEVER- Clamping, Tower2 ................................................................ ............................................. 1
32 001080 RING- Retaining ..... ........................................................................................................................ 4
33 196945 WASHER - Spacer ............. ...................................................................... .......... .............................. 4
34 102049 BEARING- Ball ......... .................................................................... ...... ............................................. 8
35 186814 CROSS SHAFT ASSEMBLY- Tower 2 ........................................................................................... . 1
36 186813 CROSS SHAFT ASSEMBLY- Tower 1 .............. ............................................................................. 1
37 001060 RING- Retaining ..... .. ....................... ............... ................................................................................ 4
38 186786 SPACER ................... ........................................................................................................ .............. . 2

MID SECTION
32, 33, 34,

35,36
'------39, 40
14, 15

MID SECTION
PNEUMATICS- NON-OPERATOR SIDE
Index Part
1 172549 BRACKET - Connector ......................................................... ............... ...................... .. ..................... 1

2 197389 PLUG - Pipe, 118 NPT ............ ......................................................................................................... . 2
3 111062 SCREWHEX .............. ...................................................................................................................... 4
4 172707 VALVE BAR ASSEMBLY .............................. .................................................................. ............... 2
5 196971 CONNECTOR - Male . ............................................................................ ............ ....... ........... ............ 1
6 197506 SWIVEL- Male Branch Tee ............. ..... ........................................................ ............ ... .... .......... ...... 2
7 197397 TEE- Union, 3/8" o.d ......................................................................... ............... ............... ................ 1
8 196977 SWIVEL- Male Elbow ...................................................... .................................. .............................. 1
9 179804 NIPPLE- Close ................. .......................................... ..... ............................. ............... .................... 4
10 172711 VALVE - 3-way Assembly .................................................... ........................ ........... ......................... 4
11 196978 ELBOW - Male .......................................................................... .................................. ..................... 1
12 173322 BRACKET -Connector ..................... ............................... .............................. ............ .. ..................... 1
13 197510 UNION- Expander ............. ......... ..................... ................................................................................ 2
14 197440 FITTING - MaleEibow ..................................................... ............................. ...... ....... .. .................... 10
15 197441 ADAPTER - Barb .......................................................................... ................ ............ .. ..................... 6
16 197507 TEE- Union, 1/4" o.d ....................... ........... ....................................... ............................................. . 2
17 197508 TEE- Male Branch Swivel. ............................................................................................................... 1
18 178401 TUBING - Roll, .170 i.d. x .250 o.d. x 500'................................................. .................................... 1
19 TUBING- .170 i.d. x .250 o.d. x 19" ....................... .................... .......... ........... ......................... 1
20 TUBING- .170 i.d. x .250 o.d. x 9-1/2" ...................................... ................ ......... ..................... 1
21 TUBING- .170 i.d. x .250 o.d. x 5-3/4" .... .... .......... ...... .............. .......... ........... .... ..................... 1
22 TUBING- .170 i.d. x .250 o.d. 11-1/2" .......................... ..................................... .. ..................... 1
23 TUBING- .170 i.d. x .250 o.d. 6-1/2" ............ .................. ...... ..... ......................... ..... ................ 1
24 TUBING- .170 i.d. x .250 o.d. 9-1/2" .................................................................. ..................... 1
25 250077 STA-STRAP ................................................................... ..... ......... ..... ........... ............ .. ..................... 5
26 172713 TUBING - Roll, Black .250 i.d. x .375 o.d. x 500' .............. ......................... ............. .. ..................... 1
27 TUBING- . Black .250 i.d. x .375 o.d. x 2-1/2" ...... .......................................... ....................... 1
28 TUBING- . Black .250 i.d. x .375 o.d. x 4-1/2" ....................................................................... 1
29 TUBING- Black .250 i.d. x .375 o.d. x 2" ........................... ............................ .. ..................... 1
30 178184 AIR PRESSURE SWITCH ASSEMBLY ....................... .............. .............. ................ ........................ 1
31 102537 FITTING-COUPLING- Hex Brass, 1/4 ........... .................................................................................. 1
32 014472 E-RING- Reinforced ........... .................................................. .......... .... .......... ............ .. ..................... 2
33 197451 TRACK ROLLER - .875 .......... ............... .............................................. ..... ........................................ 2
34 F ................................... .............. ........... ................... .............................. ................................... 2
35 197452 WASHER .......................... .............. ............................... .... ................ .............. ............... .... ........... . 2
36 102216 NUT - Zinc, 7/16-20 ............................................ ............................................................................. 2
37 186179 CYLINDER-AirlnkON/OFF ............. .... ......... ...... .............................. ...... ................. ....... ................ 2
38 186176 BLOCK- Base Pivot (J-Link) ............................ ................ ............... .... ............... ....... .... .... ............... 2
39 187958 STANDOFF - lnkAirCylinderPivot .. .................. .................. ......... .................... .............................. 2
40 001048 RING-Retaining ............... ............... .................... ...... ......... ......................... ......... ... ........ ............... 2
41 102440 SCREW - Shoulder, Hex Head, 3/8-16 ............................................................................. ................ 2
42 186177 LINK - Ink ON/OFF Swing (J-Link) ....................................... .............................. ....... .. ..................... 2

MID SECTION
13, 14, 15, 16, 23
18, 19,20,21
------17

MID SECTION
LINKAGE- NON-OPERATOR SIDE
Index Part
1 179323 ECCENTRIC ..... ............... ..... .......... ......... ...... .............. .......... ................ ......... .......... ..................... 1
2 102040 SCREW - 1/4-20 ................ .... .......... ........... .......... ..... .......... ..... .... ........... ..... ......... .......................... 4
3 003578 NUT - Hex .......................... ................... ........... ...... .... .......... .................... ..... ................................... 4
4 186801 HOUSINGASSEMBLY ... ..... ........................................................................................................... 1
5 186804 STUD - Adjustment Eccentric ........................................................................................................ 1
6 102454 SCREW - Socket Head, 3/8-16 ....... ............................................................................................... 2
7 186805 LINK - Eccentric Housing ...... .......... ................................................................................................ 1
8 178360 PIN - Clevis ........ ............... ............... .... ...... ..... ............................................. ................................... 1
9 179370 CLEVIS - Piston Rod ........ .................... .... ...... .. ........ .... .............................. .................................... 1
10 001060 RING - Retaining ................... ......................... ........... ..... ..... .... ........... ............................................ . 8
11 186799 CYLINDER - Air .. ............... ..... ......... ........... ..... ..... .......... .................... ..... ..... ................................... 1
12 186842 STAND-OFF - Air Cylinder .. ..... ......... .................... ..... ..... .......... .... ........... ..... ..... .............................. 2
13 197494 WASHER - Bearing Spacer .. ........... ..... .... .......................... .... ..... .................................................. . 4
14 180208 SPACER ........................... ..... ........... ..... ..... .... ........... ...... ........................ ..... ................................... 1
15 197343 LOCK WASHER - Bearing .................. ................ .............. .................................... ......................... 1
16 197344 LOCKNUT - Bearing ........................................ ........ .................... .......... .... .................................... 1
17 186836 LEVER - Housing Eccentric .. ......................... ........... .................... .......... ........................................ 1
18 102055 SCREW - 1/4-20 x 1/2 .................................... ..... ...... .......... .... .......... ...... ........................................ 1
19 193338 WASHER .......................... ..... .......... ..... ................ ..... ..... .... ........... ..... ..... ..... ................................... 1
20 186848 SPACER ........................... ..... ........... ..... ..... .... ........... ...... ........................ ........................................ 1
21 186813 CROSS SHAFT ASSEMBLY- Tower 1 ........................................................................................... 1
22 186814 CROSS SHAFT ASSEMBLY- Tower 2 ...... .... .......... ............................... .... ..................... .............. . 1
23 102049 BALL BEARI NG- Single Row .......................... .. ...... .............................. ........................................ 8

MID SECTION
5
6 -----1...._
~~
7
--~m~~~~,~~f~~~~~!B~J
9 ----:---.!....!..S.
Side View
r----- 43, 44, 45, 46

MID SECTION
PULL GUIDE ASSEMBLY
Index Part
1 187327 SIDE STOP • OS 00 . . .. . . . . . . . . . . . . . . . . .. . . ........ ... . . . . . . . . . . .. 1

.............................................. . .. .. .... . .... . .... . . ... .. ... . .
2 187328 SIDE STOP· nos .......... .................................................................................................................. 1

3 102157 SCREW · 10·32 ..................................... .................................... ............. ............... ... ............. .......... 4
4 186305 SCREW ...... ............ ........... .... ........... ..... .... ............................................................. .. .. ..................... 4
5 178650 SCREW - Micro-lateral Adjust ............................................. ............................................. ............... 2
6 0 14741 WASHER -Spring ........................................... ............................................................................... . 2
7 005071 WASHER ......................................................................................................................... ................ 2
8 001060 RING - Retaining ................................................................ ............... .............. ........ .. ..................... 2
9 186323 CLAMP - Pull Guide ................................................................................. ........................................ 2
10 101093 PIN - Roll ......................................................................................................................................... 2
11 186356 CLAMP .............................................................................................. ............... ............................... 2
12 101197 SCREW ............................................ ............................................................................................... 2
13 186339 CAM HOUSING ASSEMBLY- os .................... ................................................................................. 1
14 186341 CAM HOUSING ASSEMBLY - nos .................. .......................................................... .... .... ............... 1
15 102313 ROLLER- Track Crowned, 10-32 ...................................... ............................................ ................ 2
16 186312 CAM- Vacuum Head, os (for nos use 186313) ............................................................................ 2
17 102232 RING - Spirial Retaining .................................................... ......... .................... ............................... 2
18 401734 BLOCK · Coupling Drive ............................ .... ................................................................................. 2
19 186320 COUPLING- Pull Guide ....................... ......... .............................................. .................................. . 2
20 101499 SCREW - 6·32 x 3/8" ....................................................................................................................... 2
21 401733 KEY - Drive ..................................................... ................................... ......... ...... .............................. 2
22 100345 SCREW · 10-32 x 5/8" ............................................................ ................ .... .................................... 2
23 186350 BEARINGPLATEASSEMBLY ....................................................................................... ................. 2
24 001060 RING - Retaining ................................................................................ ........................ ..................... 2
25 021203 WASHER ................................................................................................. ........................ ................ 2
26 186352 STUD ............................................................................................................................................... 2
27 186353 SPRING - Compression ............................ .... .............................................. ................................... 2
28 186373 BRIDGE - Filler ... ............................................................. .... ............... ..... ........................................ 1
29 001234 SCREW · Set ...... .............. .......................................................................... ............... ..... ............... . 2
30 186304 ROD - Guide ................................................... .................................... ...................... .. ..................... 2
31 186336 FILLER - OS ........ ...... ............. ......................... ................. .... ......... ...... ..... ..... .... ........ .. ...... .............. . 1
32 186338 FILLER · nos .................... .................................................. ................ .......... ............... .................... 1
33 197502 ELBOW - 45 degrees x 5/16" ......................... .......................................................... .. ..................... 2
34 186307 GUI DE ASSEMBLY- Vacuum Head, os ........................................................................................ 1
35 186308 GUIDE ASSEMBLY- Vacuum Head, nos ...................................................................................... 1
36 112533 SCREW- 6·32 x 1/2" ....................................................................................................................... 2
37 186324 GASKET · Vacuum Head ............................... ..................... ............... ..... ................. ...................... . 2
38 186306 HEAD - Vacuum ................ .... .......... ................................ ......... .................... ......... .......................... 2
39 186302 BAR - Pull Guide Support ....... ......................................................................................................... 1
40 101483 SCREW - Cap ................................................ ................................................................................. 2
41 187330 GUI DE- Paper Height, nos ..................................................................... ........................ ................ 1
42 187329 GUIDE - Paper Height, os ............................................................ ..................... .............................. 1
43 001095 RING - Retaining ............................................................................... ............................................. 2
44 197055 WASHER - Spring ......................................... ....... ..... ........... .... .... , .... ........... ............ .. ..................... 2
45 006936 WASHER ............................................................................ ................ .......... ............... .... ................ 2
46 187326 KNOB ................................................................................................. ..................... ........ ................ 2

MID SECTION
s--..
,------9,1 0
18
'------ 22

MID SECTION
UPPER FORWARDING ROLLER ASSEMBLY
Index Part
1 179452 COLLAR · Set Screw ...................................................................................................................... 1

2 180824 SHAFT ASSEMBLY ......... ..................... ................................................. ............... ............... ......... ... 1
3 172970 LABEL- Dial ....... .............................................................................................................. ............... 1
4 100130 SCREW- Set, 10-32 x 1" ...................................................................................... .......................... 1
5 173126 BALL - Steel, 5/32" ......................... ................ .. ... ......... .................................................................. 1
6 179482 KNOB .............................................................. ................................................................ ................ 1
7 014247 SCREW- Set, 10-32 x 1/4" .............. .......................................................................... ..................... 1
8 180936 SPRING - Retaining Knob ............................. ........................................ .... .................................... 1
9 001722 WASHER- Lock ................ ....................................................................................... .. ..................... 2
10 101906 SCREW - Hex, 8-32 x 5/16" .................. ........................................................................................... 2
11 197504 STUD - Spring ................................................ .......................................................... ... .................... 1
12 081321 SPRING ................................................. ..... ..... ..................... ..... ......... .......... ...... ............................. 1
13 081789 SPACER ................... ........ ..... ........... ..... ........ ................................................................................. . 1
14 179417 BUSHING ASSEMBLY - os ............................................................................................................ 1
15 180938 LEVER ASSEMBLY - Cam Follower ...... ..... ................... .... ................ ...... ..... .... ............... ..... .... ..... . 1
16 197001 ROLLER - Track ............... ..... .............. ........... ................................................................................ . 1
17 001060 RING - Retaining .............. ................ ............. ... ............................................... ........ ....................... 1
18 179470 ROLLERASSEMBLY .......................................................................................... ............................ 1
19 014386 SETSCREW - Nylok . ....................... ................ ......................... ............................... ....................... 1
20 180933 PIN - Bearing ..... ..... .......... .............................. .. ..................................................... ......... ............... . 1
21 179480 BUSHING -nos .......................................... ..... ................................................................................ 1
22 102511 SCREW - Cap,Biack, 1/4-20 x 3/4" .. ............... .. ................. ..................... .... ........... .... ..................... 4

MID SECTION
FRAME N.O.S.
FRAMEO.S.

MID SECTION
MASTER CYLINDER
Index Part
1 197485 SPRING - Die .................................. ..... .......... ........... ...... .............. ..... ............................................. 1
2 172403 SCREW - Drive ...................... ............................. ...... ..... ..... .... ................ .... ..... ............................... 2
3 172404 INSERT- Brass .............................................. ................................................................................. 2
4 197486 SPRING- Die .................................. ..... ......... .................................... ............................................. 1
5 197485 SPRING - Die ........................ .......... ..... ................................................... ........................................ 1
6 197106 FITTING- Grease ............................. ............... ............................ ................ ............... .................... 1
7 180362 SEAL- Grease ................................ ............... ......................... .......... ............................................. 1
8 186665 RING- Master Cylindler, T-1 ............ ...... ......... .. .. ................ .................... ..... ............ .. ..................... 1
9 172402 DOG - Drive ........ ............... ................... ..... ....... .. ...... ..... ..... .................... ..... ............ ....................... 1
10 102019 BEARING- Needle, Thrust ............. ............... .. ....... ................. ..... ......... ................. ....................... 1
11 196830 WASHER - Thrust ............................. .... ............................................. ..... ..... ..... ....... .. ..................... 1
12 180361 SEAL- V-Ring ...... ....................................................... ..... ...... .... ............... ..... ........... ....................... 1
13 179151 GEAR -Rot. Adj . ................................................................................. ..... ..... ............ ....................... 1
14 101756 SCREW - 3/8-16 X 1" ....................... ..... ............ ................................. ..... ......... ........ .. ..................... 3
15 186655 HUB - O.S......................... .............................. ..... .... ..... ..... ..... ...... ..... .... ...... ............ .. ..................... 1
16 102303 SCREW- 3/4" X 1/4-20 ......................... ............ .. ...... .............. .......... ...... ..... .... ........ ....................... 1
17 102462 PIN- Dowel, 7/16" x 1-1/4" .............. ..... .......................... ......... .......... ...... ......... ........ .. ..................... 1
18 196832 FITTING - Grease ................... .......... ..... .......... ..... .... ..... ..... ..... .... ..... ...... ..... ..... .............................. 1
19 186667 PLATE· Thrust ... .............. ................ ..... ........... ... ..... ..... .... ..... ........... ..... ..... .... ........ ........... ........... . 1
20 186113 GEAR - Helix .................. ........................ ......... ................ ............... ........................... .. ..................... 1
21 186669 NUT - Bearing ..................................................... ........... ..... ......................... ..... .... ... ....... ................ 1
22 197467 BEARING- Tapered Roller .............. .......... ..... .... .......... ..... .... ................ ..... .......... ........................ . 1
23 197469 SEAL - Nilos Metallic Bearing .......... ..... ........... ... ..... .... ........... ..... .......... ...... ........... ....................... 1
24 197497 WASHER - Bearing Spacer ......................................................... ............... ............. .. ..... .... ............ 1
25 186668 SHAFT - Master Cylinder ................. .... ..... .......... ...... ..... .... ............... ...... ..... .... ........ ....................... 1
26 186115 CYLINDER - Master, T-1 .................. ..... ..... .... .. ........ ..... ..... .... ..... ...... ..... ..... ..... ....... .. ..... ................ 1
26 186116 CYLINDER- Master, T-2 .................. ..... ......... ............... ..... ......... ...... .......... ............ .. ..... ................ 1
27 173370 NUT - Bearing Preload .............................. .... ......................................................... ....................... 1
28 102243 SETSCREW - 1/4-20 ...................... ..... ................ ..... .... ..... ..... ...... .... ............... ............... ................ 1
29 172947 INSERT - Brass ..................................... ..... .......... .......... ..... .... ..... ...... ..... ..... ...... .... ......................... 1
30 173371 SPACER - Bearing Preload ....................... .... ..................... .................... ........................................ 1
31 197469 SEAL - Nilos Metallic Bearing .......... ..... ........... ... ..... .... ........... ..... ..... ..... ...... .................................. 1
32 197467 BEARING - Tapered Roller ..... ............. ...... ............................................ ..... ...... ............. ................ 1
33 186778 SPACER - Bearing, Nilos ........................... ......... ................................................... ......................... 1
34 197471 SEAL - Nilos Metallic Bearing .......... ..... .... ............ ............... ..... .... ..... ..... ...... .... ..... ......................... 1
35 186775 HUB - Flanged, Eccentric ................. .............. ......................... .................... ................................... 1
36 179171 CLAMP - Bearing .... ........................................................................... ..... ......... ........ ....... ................ 1

MID SECTION
I
4 I /'.
I/
, /r
...____...
I 11
I
I 12
I
I
I
9
2 - - - - --"
13

MID SECTION
PLATE CLAMP ASSEMBLY
Index Pa rt
1 173943* CLAMP - Plate Cylinder . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . 0 0 0 0 0 0 0 0 . 0 0 0 0 0 0 OoOOOO 0 0 0 0 0 0 0 0 . 0 0 0 0 . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . 0 0 0 0 0 0 0 0 0 0 0 . 00 00.000 00 00 0000 0000 00 0 1

2 173400 PLATECLAMPASSEMBLY ooooooooooooooooooooooooooooooooooooooooooooooooooooooooo o oooooooooooooooooooooooooo o oooooo o oooooooooooooooo 1
2 172731 CLAMP - Lead 000000 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 OO OoOO o o o o · 0 0 0 0 0 0 0 0 0 0 0 0 o o o o · 0 0 0 0 0 0 0 0 0 o o o o · 0 0 0 0 0 0 0 0 0 0 0000 000 00000 00 00000000 0000 0000 1
2 172732 CLAMP- Trail 00 .oo oo • • oo • • o o o o o o o o o o o o o o . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 OoOOOO 0 0 0 0 . o o o o o o o o . o o . . o o 0 0 0 0 0 0 0 0 0 0 0 0 0 0 o o o o . 0 0 0 0 0 00 000 00 oo. 00 00 00000000 00 oo. oo . 1
3 173158 INSIALLATIONTOOL oo ooooooooooooo oooooooo o oooo oo oo oooo oo oooooo ooooooooo oo oooooooo ooo oo oo oooooooo ooo oo oooo ooo oo o oo oo oo oooooooo oo oo o oooo 1
4 180881 RETAINER- Base, N.O.S. OO o o OOOOOOOOOOOOOOOOOOOOOOOOOOO OoOOOOOOOOOOOO OOOOOOOOOOO OOOO OOOOOOOOOOOOOOOOOOOO O OOOOOOOO O OOOOOOOO OO OO OOOO OOOOO 1
5 172437 PUSHER -Plate Clamp 00000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000 00 000000 0000 000000 1
6 172438 CRANK 000000000 0 00 00000000 0 00000000000000000 00 00 000 00 00 00000000 00 00 00000000 00 000 00000000 00000000000000 00 000000 00 00 0000000 0 00 00 0000 0000000 00 000000 1
7 102291 SCREW - 1/4-28 X 1" 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00000000 00 00 0000 00 00 00 0000 0000 000 00 000 00 00 0 0 0 00000000 0000 0000 2
8 102290 SCREW - 1/4-28 x 3/4" 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 4
9 180581 SPRING - Nose OOOOOOO O OO OO OO OOO OO OOOOOOO OOOO O OOO OO OO OOO OO OOOO OoOO OOOOOO OOOO O OO OOOOOOOO 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00000000 0 0000 0 0000 00 00 00 000000 1
10 197168 SPRING · Compression 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . . . . OO oO OO 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 o o o o • 0000 000 • • 0000 0 0000 00 00 00 . . 0000 1
11 197209 SPRING - Compression 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 OO oO OO o o o o · 00000 000000 0000 0000.0000 000000 00000 0000 0 00 00 000 • • 0000 0 0000 00 00 0000 0000 1
12 172223 PIN - Preload 00000 000 00 00 0000000000000000 000 00 00 000 00 0000000 0000 0 000 00 00 0000 0 0000 0 00000000 000 00 00 0 0000000000000 00 00 00 0 00 000 00 00 00000000 00 000 00 0 1
13 172399 GUI DE· Trailing, O.S. oooo•oo•ooooooooooooooooo . . . . o o . . . . . . . .. . . oo . . . oooo . . . . . . . oo oo . . . . . . . . oo oooo o oooo o oo oo oooooooo . . . . . oooooooooooo . . . . . . 1
* Affix green tag and return part if found defective.

MID SECTION
, - - - - - - - - - -12
3 -------.... , - - - - - - - -11
, - - - - -13
, - - - - - - - 15
, - - - - - - - - -17
, - - - -16
12 ---~
11 ---------...._
13 ----------.._
15 - - - -
21

MID SECTION
BLANKET CYLINDER
Index Part
1 179504 BLAINKET/CLAMPASSEMBLY ....... ..... ......... .... .. ..... .......... ...... ..... ......... ......................................... 1
2 173666 BLANKET· Clamp Top .......... .................... ......... ..................... ................... ..... .................. ............ 2
3 173667 BLANKET - Clamp Body ................................ .................................................................... ............ 2
4 014151 SCREW - 10-32 X 1/2" ····· ······ ·········· ···· ···· ...... ... ... ..... ..... ............... .............. ............. ······················ 20
5 102173 SCREW - Set, 1/4-28 ........ ..... .............. ...... .................... ...... ..... ......... ...................... ....................... 4
6 197394 SCREW - Blanket/Clamp .. .............. ..................... ......... ..... ...... ...................................................... 8
7 186117 BLANKETCYLINDERASSEMBLY ............................ ......... ...... ...................................................... . 1
8 100392 SCREW - Insert .. ............................. .......................... .......... ............... ......... ...... ....... ....... ................ 4
9 186114 GEAR - Blanket Helix ........ .............. ...................... .... .......... ...... ...................................................... 1
10 102410 SCREW - W I Flange, 5/16-18 x 1" bLACK ........ .................... .......................... .............. ................ 4
11 197468 BEARI NG - Taper Roller .. ................ .............. ........... ...... ..... ........................ ..... ............................. . 2
12 197493 SEAL - Shaft Blanket Cylinder .......... .......... .... ................. ................................................................ 2
13 197470 SEA L - Nilos Metalic Bearing ................................ .............. ................ .............. .............. ................ 2
14 186123 CYLINDER - Blanket ........ .................................... ..... ...... ..... ............................. .............. ............... . 1
15 186777 SPACER ........................... ..... ..................... .......... ..... ...... ..... ........................ .... ................ .............. . 2
16 197489 NUT - Bearing Lock .................................... ................................... ..... ................... .......................... 2
17 197488 WASHER- Bearing Lock ................ ............... ..... ...... .... ..... ................ .............. .......... ...... ............... 1
18 180208 SPACER ........................................... .......... .......... ..... ...... ..... ................... ..... ................................... 2
19 197343 LOCK WASHER - Bearing ............................. ................................... ............................. ............... . 2
20 199344 LOCK NUT · Bearing ................................................ .......... .................... ........................................ 2
21 186670 SHAFT - Blanket Cylinder Eccentric .................................. ............................... ....... .. ..................... 1

MID SECTION
- - - -18
~-- 19
,.----20
r--21
3~~ •• •• • < 13 •• ;)
1 ~~~ 9 } ,.-....,,
..... ~ 10 ,""l 12 '>
<. . , 11 ,""
',, ,"
..........
....
-
, ,"'
24- - - - - - - - '

MID SECTION
IMPRESSION CYLINDER
Index Part
1 172600 BLOCK ASSEMBLY- Bearing ........................................................................................................ 2

2 102239 SCREW - 1/4-20 X 1-1/2" .. ..... .......... ............................................. ......... ......................................... 4
3 197137 WASHER - Nylon ............................................................................................................................. 4
4 197135 PIN- Dowel .. ................................................................................................................................. 12
5 173219 FINGER - Gripper ............................................ ............................................................................... 12
6 180349 PLATE - Retainer Gripper .................... ...... .............................. ......................... .... ......................... 12
7 102143 SCREW - Allen, 5/16-24 x 5/8" ........................................... ......... ................ .................................. 12
8 172598 BAR ASSEMBLY - Gripper ............... ............... ...................... .................................. .. ....................... 2
9 178527 PIN - Pivot ........................................................................................................................................ 2
10 001781 RING- Snap ...... ................................................... .......... ................................................................. 2
11 178572 GUI DE ASSEMBLY- Spring ............. ................... .................................................... ....................... 2
12 015369 PIN - Cotter, 1/ 16" x 1/2" .................. ................................................... ............................................. 2
13 197132 NUT • Special ........................................................ ..... .... ................................................................. 2
14 190254 NUT- 3/8-24 ...... ............................... .............. ................................................................................. 2
15 102216 NUT - 7/16-20 ................... .................................... ..... ...................................................................... 2
16 197452 WASHER- Split ....................................................................................................... ........... ............ 2
17 102136 ROLLER- Tack ................ ............... ................................................................................................ 2
19 178528 GUIDE- Spring ...... ........................................................................................................................ 2
20 178416 BRACKET · Anchor, Spring .............. ......... ........... .... ...................................................................... 2
21 102144 SCREW - Socket, Head Cap .......... .......................... ..... ................................................................. 4
22 186789 CYLINDER - Impression ............................................................................................................... 1
23 197467 BEARING- Tapered Roller ........... ..... ..... ..... ..... ..... ..... ................................................................. 1
24 197492 SEAL- Face, V-Ring ..................... .......... ............... ...... ................................. ............................... 1
25 197468 BEARING- Tapered Roller .. ......... ...................................................... ...... ..... .............................. 1
26 197470 SEAL- Nilos Metallic Bearing ...... .... ........... .... .... ..... ................................................................. . 1
27 102452 WASHER - Steel ............................................................. ................................................................. 1
28 102453 SCREW- Zinc, 7/8-9 x 2-1/2" ................ ...................................... .......................... .. ....................... 3
29 186780 WASHER ............................... .......... ..... ................................................................ .......................... 1
30 186777 SPACER- os and nos ...... ............... .... .......... .. ... ..... .... .................................................................. 2
31 197495 NUT· Clamp, NT-11 ......... ......................... .............. ...................................................................... 2
32 197473 BUSHING -Expanding, Tran Torque .... ..... .............................................................. ....................... 1
33 186671 SHAFT - Impression Cylinder

MID SECTION
~--- 6
"------ 16
'------17
'----- 18
'-----19
'-----20, 21

MID SECTION
TRANSFER CYLINDER- PART 1
Index Part
1 100891 SCREW - Cap, 7/16-20 ........... ......... .................... ..... ................ .............. ..... ............ ....................... 4
2 173715 ANVIL - Gripper .. ............... ...... ......... .......... ......... ..... ..... ..... ...... ..... .... ..... ..... ...... .... ......................... 1
3 197452 WASHER ............ ................... .......... ..... ................ ..... ......... ........... ..... ..... ..... .... ............................... 1
4 102216 NUT- 7/16-20 ..... .............. ..... ........... .... .......... .......... ..... ...... .............. ...................... ....................... 1
5 197454 FOLLOWER - Cam ............ .... .............. .................................................. ........................................ 1
6 173729 CLAMP - Cam .................... .... ................ ..... ... ............ ................................... ..... ....... ....................... 1
7 197511 STANDOFF .............. ........ ............... ..... ......... .... ............ ................................................. ................. 1
8 100625 SCREW - 1/4-20 X 1/2" ..... ..... ............... .... ..... ... ... .......... .................... .......... .... ........ .. ..................... 1
9 186404 INDilCATOR ....................... .... .......... ...... .... .... ................. ...... .... .... ........... ..... ................................... 1
10 173821 SLEEVE ............. .................... ............... ......................... ...... .... ..... ............... ................................... 3
11 102300 SCREW - 1/4-20 X 1/4" ..... ..... ........... .... .... ............ ..... ..... .................... .......... .... ........ .. ..................... 3
12 173759 SPACER ............ ............... ................ ..... .................... ...... ..... ................... ..... .... ............................... 1
13 001771 WASHER ............ ................... .......... ..... ......................... ............... .......... ..... ................................... 1
14 001763 WASHER - Lock .............................. ..... ............... ...... ..... ..... .... ................ ..... ............ .. ..... ............... . 1
15 178495 SCREW .................. ............... ........... ..... ........ ....... ............... ...... ......... .......... ............ ....................... 1
16 173810 DIAL ................... .................... ............... ............ ........ .................... ..... .... ...... ............ ....................... 1
17 102303 SCREW - 1/4-20 X 3/4" ..... ................ .... ..................... .............. ................ ................. .. ..................... 3
18 173728 SPROCKET ....................... .... ............... ............... ..... ..... ...... ..... .... ..... ............................................. 1
19 172516 CAM - Valve ....................... .... ............... ........... ..... ..... ........... ..... .... ..... ..... ................. .. ..... ............... . 1
20 178827 RING- Cam ........ ............... .... ................ ........... ............. ......... ................ ..... ............ .. ..................... 1
21 001980 PIN ........................ ........... .... ........... .... ............... .......................... .... ................ ............................. 1
22 172517 CAM - Bar ........... .... ................ .......... ..... .... ..... .. .... ......... ..... ..................... ..... .............. ................... . 1
23 173727 HUB - Cam ......... .... ................ ......... ............... .... ..... .......................... ..... .... ..... ...... .... ..... ................ 1
24 173750 KEY1
25 102304 SCREW - Set, 1/4-20 x 1/2" .. .......................... .. .. ..... ........... ..... ..... .................................................. 1
26 178830 CAM - Stop Finger ............ ..... .......... ......... ......................... ............... ......... ...... .......... ..................... 1
27 173730 BEARING ........... ................... ........... .... .......................... .... ................ ......... ............... ..... ................ 1
28 100806 SCREW - Socket Head, 1/4-28 x 3/4" .. .................................. ........... ...... ........................................ 1
29 173735 BLOCK ............... ............... ...... ..... .... ............... ...... .... ..... .......... ........... .... ........................................ 1
30 172403 SCREW· Drive ................. ..... .......... .............. ....... ..... ...... ........ ................ .... ............... ..................... 1
31 172404 INSERT - Brass .. ............................. ...... ..... .... ...... ................................... ............... ..... .... ................ 1
32 014386 SCREW - Set, Nylok ......... ..... .......... ..... .......................... .... ..... ................ ..... .... ........ .. ...... .............. . 1
33 014784 WASHER .......................... ..... .......... ..... ................ ..... ......... ................ ..... ..... .... ..... .......................... 1
34 190129 SCREW. 5/16-18 X 1/4" ........ ......................... ..... .............................. .............................................. 1
35 173659 GRI PPER ............ ......................... .... ..................... ..... ............... .......... ..... .... ..... ........... .... ............... 7
36 173746 BRACKET- Roller ........... ................ ..... .......... .. ............. .......... .................... ................................... 2
37 173744 SHAFT - Roller ... ............................................ .............................. .......... .... ..... ...... .... ..... ............... . 2
38 173745 ROLLER ............ ..... ......... ...... ........... .... .... ........ .. ...... ..... ..... .... ..... ..... ........... .... .......... ..... ................ 2
39 173734 END DISK - O.S.. ................ .... ......... ........... .... .... ........... ...... ......... .................... ....... .. ..... ................ 1

MID SECTION

MID SECTION
TRANSFER CYLINDER- PART 2
Index Part
1 173739 GUI DE - Spring ............................................................................................................................... 2

2 100891 SCREW - Cap, 1/4-20 x 1" ..................................................................... ........................................ 4
3 197137 WASHER- Nylon ............................................................................................................................. 2
4 173755 BLOCK- Bearing, N.O.S................................. ............................................................................... 1
5 100890 SCREW - Set ................................................................................................................................. . 1
6 172404 INSERT - Brass ............................................................................................................................... 1
7 014381 SCREW - Set, Nylok ........................................................................................................................ 1
8 173736 LEVER -Cam Follower .................... ............... ............................... ................................................. 1
9 102142 PIN -Taper ................................................................. ..... ............................. ................................... 1
10 173726 SHAFT ............................................................ .................................. ........................ ...................... 1
11 190129 SCREW - 5/16-18 x 11/4 ............................................................ ............... ........................................ 3
12 102040 SCREW - 1/4-20 x 1-1/4" .. ............................................................ ............................. ..................... 2
13 100891 SCREW- Cap, 7/16-20 ................................................................................................................... 2
14 102040 SCREW - 1/4-20 X 1-1/4" ........................................................................................... ..................... 3
15 173732 DISC - Inter ................................................................ .... ............................. .................................... 6
16 173737 DISC - Retaining ............................................................................................................................. 1
17 102073 SCREW- 5/16-18 x 1-1/4" .............................. ......................................................... .. ..................... 4
18 173743 BLOCKTUBEASSEMBLY .... ....................................... ................ ......... ......................................... 1
19 102303 SCREW- 1/4-20 X 3/4" ..... .............................................. ..... ......................... .... ........ .. ..................... 2
20 102040 SCREW - 1/4-20 x 1-1/4" ........................................................................................... ..................... 1
21 100653 SCREW- Cap, 1/4-28 x 3/4" ............ ...................................................... .... ............... ..................... 3
22 102302 WASHER -Spring .. ........... ................................................... ........................ ............ .. .................... . 8
23 173816 PLATE - Pressure ..................................................... .......... ............... ...................... .. ..................... 1
24 102256 E-RING -Bowed .............................................................................................................................. 2
25 173731 HOUSING - O.S . ..... ......... ............................................... .... .......................... .............. ..................... 1
26 01 4123 SCREW - Socket, 5/16-18 x 1-1/4" ..................................................... ........................ ..................... 1
27 195234 WASHER ........................................................................ ................................................................. 1
28 173756 GEAR .................................................................................................. ............................................. 1
29 173033 CAM - Forwarding .............. .............................................. .... .............................. .............................. 1
30 173802 BEARINGASSEMBLYBLOCK ................................................ ......... ........................ ...................... 1

MID SECTION
3, 4, 5

MID SECTION
TRANSFER GRIPPER BAR ASSEMBLY
Index Part
1 173748 TRANSFER CYLINDER GRIPPER ASSEMBLY ..................................................... ......... ............... 1

2 197137 WASHER· Nylon ......................................................................... ................................................... 2
3 173755 BLOCK · Bearing ............. .............................................................................................................. 1
4 100890 SCREW- Set, 1/4· 28 x 3/4" .............................................................................. .............................. 1
5 172404 INSERT · Brass .......................................... .... ..................... ........................................................... 1
6 100891 SCREW · Cap, 1/4·20 x 1" .......................................................... ............... ............... ..................... 4
7 102040 SCREW· 1/4-20 x 1-1/4" ................................................................................................................ 4
8 173746 BRACKET · Roller .......................................... ..................... ............................ ............................... 2
9 173744 SHAFT - Roller ............................................... ................................................................ ................ 2
10 100891 SCREW - 1/4-20 x 1" ...................................................................................................... ................ 4
11 173745 ROLLER ............................................................................. .............. ............... .......... ..................... 2
12 173739 GUI DE· Spring ............................................................................................................................... 2
13 197453 SPRING · Comp .................... ..................................................................................... .... .... ............ 2
14 173743 TUBE· Block Assembly ..................................................... ............................................................ 2
15 102073 SCREW· Socket Head, 5/16·18 x 1-1/4" ....... ................ ................................................................. 4
16 173738 ROD · Spring .......... .......................................... .............................................................. .... ............ 2

MID SECTION
1' 2 - - - - - - - -
, - - - -14
3 --------.
, - - - - - 13
4-----.
,-------------1
r - - 49
I NOS 45 48 so l
I 24 1
1 46 s1 1
I 47 23 J
I I
I 3s I
I 42 ,~,~- 52 1
44 ~w
29
30 IL Top View I
_____________ J
OS NOS
37
38
33
39
HH---~ ~--- 40
34
41
Top View
43
~ 22
17 ~~
: ~~~~~~~~
20
~~~~
~~rr 2~24 Rear View 25 21

MID SECTION
STOP FINGER ASSEMBLY AND GUIDE

Index Pa rt
186359 BLOCK· Mounting, N.O.S................ .............................................................................................. 1

2 186358 BLOCK · Mounting, O.S. .................. ..................... ............... ....................................... ..................... 1
3 186331 GUIDE- Front Paper ................................................. ...... ..... ........................................................... 1
4 014151 SCREW- 10-32 X 1/2" ..................... .... .......... ... ... ....................................... .................................... 2
5 001845 NUT - 3/8-24 ..................................... ............................................................................................... 2
6 186406 SCREW - Leveling ....................................................... ................ .............. ............... .................... . 2
7 102235 SCREW · 10-32 x 7/8" .................................................................. .............. ............... ..................... 2
8 100347 SCREW - 6·32 X 3/8" ...................................................... .............................. ............ ... .................... 4
9 186473 CLIP- Wire ...................................................................................................................................... 2
10 100137 NUT - 2·56 .................................................. .... ........... ..... ...... ........................................................... 2
11 100490 SCREW - 2-56 x 1/2" ................................................. ...................................................................... 2
12 172988 SENSOR - Transfer ........... ............................. ................................................................................. 1
13 102055 SCREW- 1/4-20 X 1/2" .............................................. ..... ..... ............................. ........ .. ...... ............... 4
14 186474 GUI DE· Paper ............................................... .. ............................ ......................... ......................... 1
15 186333 PAPER GUIDE - Upper .................................. ...... ............................................. .............................. 1
16 101499 SCREW . 6-32 X 3/8 ....................................... ...... .......... ...... ........ ................ ................................... 2
17 186326 STUD - Shoulder .............................. .... .......... .. ... ...... .... ............................. .................................... 1
18 186368 STANDOFF ...................... .................................................................................... ........................... 1
19 074724 SPRING ................................................................ ................ .......... .... .......... ................................... 1
20 186325 STOP FINGERASSEIMBLY ...................................................... ......... ............... ....... .. ..................... 1
21 001781 RING · Snap ................................................... ................................................................................. 2
22 186375 CRA NK • Stop Finger ........ ............................. ................................................................................. 1
23 000666 WASHER - Lock ................................................. ...... ..... ..... .............................. ....... .. ...... ............... 2
24 100334 SCREW· 10-32 x 3/41" ............................................................ ................ ........................................ 2
25 014703 WASHER ................................................................... .................................................. .................... 1
26 001710 WASHER - Lock, .320 i.d., .570 o.d. ..... ................................... .......... ....................... .. ..................... 2
27 001834 NUT - Hex, 5/16-24 ......................................... .......................... .............. ................ ........................ 2
28 179457 SHAFT - Drive Gear ............................................... .......................................................................... 1
29 173309 GEAR .................................................................................................. ............................................. 1
30 173312 GEARASSEMBLY .......................... .......... .......... .... ................................................... ..................... 1
31 172337 SHAFT - Drive Gear ............................................... .... ................ .................................. .................... 1
32 001080 RETAI NINGRING ....................................... .... ................................................................................. 2
33 111074 SCREW - 1/4-28 X 3/4" ........................................................ ..................................... .. ..................... 2
34 172274 HOUSING - Bearing, os ............................................ ...................................................................... 1
35 172948 LINKASSEMBLY ................................................................................ ............................................. 1
36 173649 ROLLERASSEMBLY ....................................... ....................................................... ....................... 1
37 179720 HOUSING - Clamp ............................................................ ...... .... .............................. ..................... 4
38 101086 SCREW - 1/4-28 x 3/4 ............................................................................................. ....................... 4
39 172870 DISC - Bearing Preload ........................ .................... ............................................... .. ..................... 1
40 196992 SPRING - Compression ................................................ ...... .... ............... ..... ................................... 1
41 172273 BEA RING - Housing, nos ............................................................................................ .................... 1
42 001060 RETAI NING RING ...................................................... ...... ............................. ................................... 1
43 197504 SPRING ANCHOR .................................................... .... ..... .......... ........... .... .................................... 1
44 178741 SPRING • Extension ....................................................... ...... ......... ................................................. . 1
45 197052 BEARI NG- Thrust ........................................................................................................................... 2
46 014808 NUT - 10-32 ....................... ..... ............... ..... .... .......................... .... ..... ..... ...... .................................. 1
47 014158 SCREW- 10-22 x 1/2 ................................................ ........................................ .............................. 1
48 072304 SCREW - Shoulder ........... ................................................................. ...................... .. ..................... 1
49 102128 BALLBEARING .. .............. ..... ............... ......................................... ............... .... ........... .... ................ 1
50 001778 RING- Snap ............................................................................................... ............... .................... . 2
51 173052 FOLLOWERASSEMBLY ................................................... ................ ............................................. 1
52 178654 CRA NK ............... .............. ..... ........... .... ............ .... ........................ .......... ......... ........ ........ ............... 1

MID SECTION
- --3
'-----4
'----5

MID SECTION
TIE BARS
Index Part
1 102064 SCREW- 3/8-16 X 1-1/4" ................................................................................................................. 4

2 186653 STRAP - Mid INk Tower .......... ......... ...................... ......... ..... ................ .... .......... .......... .................... 2
3 100490 SCREW - 6-32 X 1" ................ ............... .............................................. ......................... .............. ...... 2
4 100137 NUT- Hex, 6-32 ........ ................................................................................................ ........... ............ 2
5 172988 SENSOR- Transfer ......................................... .. ... ......................... ............... .... ............................... 1
6 186474 GUI DE - Paper .......... ............................. ......... .............................................. .... ............................... 1
7 102064 SCREW - Socket Head .................... ...... .................... ...... ........................ ........................................ 4
8 186652 BRACE - Mid Section .......................................................................... .... ................. ....................... 2
9 196909 SCREW- Dowel ............................................................... ............... ......... ................. .... ................... 2
10 102566 SCREW- Machined, Black , 3/8-16 x 1-1/4" ............. .................... .......... .......... ............................. 20
11 102040 SCREW- 1/4-20 x 1-1/4" ................................................................................................................. 2
12 102066 WASHER .................. ............................ ............ ... ..... ......... ................ .......... .... ........ ....................... 4
13 179553 BAR- Tie .................. ................................................. ..... .... ................ ..... ..... .... ............................... 1
14 100625 SCREW- T94N ...................................... ..... .... ................................................................................. 2
15 186412 BRACKET ....................................... ..... ............. ... ..... ......... ........... ..... ............................ ................. 2
16 001812 NUT- Hex, 10-32 ....... ......... .............. ..... .............................................................................. ............ 2
17 100339 SCREW- Cap ........... ......... ...................................................................................... ....................... 2
18 186466 BRACE- Lower ................................................................................................................................ 2
19 100130 SET SCREW -10-32 x 1" ............................................................................................................... 2
20 186303 TIE BAR · Pull Guide . ......... ............... .......... ..................... .......... .... ................ .... ............... ............... 2
21 186332 TIE BAR- Guide Plate ................................ ............................... ........................ ....... .. ..................... 2
22 100813 SCREW - 1/4-20 X 1-1/ 16" ............................... ........................................... ...... .............................. 2
23 186374 BRACE-- Feeder ...... ........ ......................................... ..... .... ................ ......... ..................... ............... 1
24 100653 SCREW ............................. ......................... ............... ................ ................... ............ .. ..................... 2
25 014165 SCREW ................................. ..................... .......... ..... ........... ......... ............... .............. .................... . 2
26 001731 WASHER- #25 ......... ....... ............... ................ .. ........ .... ................ ......... .................... ..................... 4
27 005071 WASHER .................. ........ .............. ...... ............ ... ..... ..... .... ................ ..... ......... ............... ................ 4

MID SECTION
2
.........
' '\. \
Tower #2 \ ( Tower #1
,....---,-------,\
\ I
\ \. /
/
" /
0
/
/
0
/
/
/
1 /
/ 4
..... .....
/
3
4 5

MID SECTION
ATTACHING THE BASE, MID AND TOWERS
Index Part
1 102581 SCREW- Mach., Black, 3/8-16 x 1 1/2" ........... ......................................................... ....................... 8

2 102566 SCREW- Mach., Black, 3/8 -16 x 1 1/4" ..... ....... .. ................ ..... .... ..... .......... ..... .............................. 4
3 101756 SCREW ............................................ ............. ........................................................... ....................... 4
4 102566 SCREW- Mach., Black, 3/8-16 x 1 1/4" ........... ............................................. ............... .................... 6
5 186488 PIN - Diamond ..................................... ............................................. ............................................. 2
6 186487 PIN .......................... ......... ............... ............... ................................................................................ 2

MID SECTION
-------- 2

MID SECTION
DRIP PANS
Index Part
1 102418 SCREW - Socket, Black, 1/4-20 x 1/2" .......................................................................................... 4

2 179698 PAN - Drip ..................................................................................................................................... 1
3 001731 LOCKWASHER ............................................................................................................................... 4
4 179697 PAN - Drip ..................................................................................................................... .... .......... ... 1

UNIVERSAL FEEDER

UNIVERSAL FEEDER
~
1
/
I 2
I
\ 6
3
"' ' - 4
5
,.--8
\
\ 7
"'1
\
"-...

UNIVERSAL FEEDER
FEEDER SIDE GUIDE SPROCKET'S
Index Part
1 100119 TRU·ARC CLIP · Bowed ................................................................................................................. 4

2 072064 BUSHING ......................... ..... ......................... ........................................ .... ................... ................. 4
3 180548 BRACKET · Guide Screw ...................... ..... ..................................................................................... 2
4 084473 GUI DE NUT ASSEMBLY ........................ ......................................................................................... 4
5 100119 TRU-ARC CLIP · Bowed ...................... ...... .... ........... ..... ................................................................. 4
6 007533 GUI DESCREWASSEMBLY .. ...... ......... ................ .... .................................................. .................... 4
7 150086 NUT- Flange, 5/16-18 ..... .................... .......... .. .. ..... ...... ..... .... ....................................................... . 4
8 102570 SCREW· Hex Flange, 5/16-18 x 3/4" ............................ ......... ................................. .. ..................... 4
9 01 4784 WASHER" ......... ............... ............... ..... ........... .. ... ..... .... ..... ..... ...... ............................. ..................... 4

UNIVERSAL FEEDER
2:3
24
x-22
............
~
~
I
'
I
26 ,27
--
-.......... /
;-- -
/ '\, / /
'(
J Front View Left Side View
I
1
2
3------"
4
:~--~~~-----_rf-~1~~-~M- 5,6, 7
'--
16, 17
--'C- 12
10----'
11
' - -15, 18

UNIVERSAL FEEDER
PAPER GUIDE RAILS
Index Part
1 016327 SCREW - 10-32 X 9/32" ... .... .......... ...... ......... .... ................. .... .... ............ ..... .... ..... ........... ............... .. 4
2 016060 SCREW - 10-32 X 3/8" ................................. ..... ......................... .... ................................... .............. 4
3 173511 GUIDE ASSEMBLY- nos .................................. ......................... ...... ..... ..... .... ..... ...... ..... .... ............. 1
4 173509 GUIDE ASSEMBLy - OS .. .......... .... ..... ..... ...... .............................. . ........ ............... .......... .................. 1
5 072599 BRACKET - Bearing, os, nos ........................... ...... .............. .......... ...... .............. ........... ................. 2
6 111054 SCREW- 10-32 x 1/2", os, nos ......................... .......... .... .......... .. ....................... ............... ............. 6
7 0 14248 NUT - Lock, 10-32, os, nos .............................................. .... ......................................... ................. 6
8 072024 CHAIN ASSEMBLy - OS 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 00 0 1
00 00 00 00 000 00 00 00 00 00 00 0 00 00 00 00 00 0 00 00 00 00 0 0 0 0 0 . 0 0 0 0 0 0 0 0 0 0 0 . .. .. . 0 0 0 0 0 0
9 072037 CHAINASSEMBLY ........................ ......... ..... ........... .......... .... ................ .............. ............................ 1
10 173442 CHAIN (To Table Raise Motor) ..................................................................................................... 1
11 001093 RETAINING RING .... ...... .................................... ..... .... ..................... .............................. .... ............. 2
12 173438 TABLERAISE!LOWERSHAFT ASSEMBLY ..... .............................. .............................. ................ .. 1
13 072599 BRACKET - Bearing ...................... ................ ......... ..... ........... ......... ............................... ............ 1
14 173436* INNER RING 1" o.d . .... .................... .......... ..... ..... ......... ..... ........... .............................. .... ........... .. 1
15 001936 PIN · Taper ... ....... ...................... .... .............................. ............ ................................................... 2
16 196997 WASHER- Thrust ........................... ........................................ ..... .... ..... .......... ...... .................... .. 1
17 001073 RETAINING RING ....... .............................. ......................... ...... ... ............... ..... ............................ 1
18 072041* SPROCKET ................................ .... .................................................. ......... ..... ...... ..... ................. 2
19 173439* SHAFT .......... ........ ...... ...... ......... ................ .............. ..... ..... .......... ............................. ................... 1
20 100345 SCREW- 10-32 x .312" .............................................................. 4 0 0 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . .
21 001812 NUT - Hex, 10-32 .... ....... ..................... ..... ... ..................... ......... ...... .............................. ..... ......... ... 4
22 112652 SCREW- 8-32 x 9/ 16" .......................................... 4
0 0 . . . . . . . . . . . . . . . . . . . . o o . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . o o . . . . . . . . . . . . .
23 180670 BLOWER - Front ...... ....................................................................................................................... 2

24 180653 SCREW - Knurled ... oo. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . ... .. ... .. ... .. .. .... . 2
....... .... .. .. .............. . . . . .. . . . . . . . . . . . . . . . . . . . . . . .
25 180671 HOLDER - Front Blower .. 2

00 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 00 . . 00 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . oo . . . 0000.
26 173514 SPACER FINGER - os .......................................... ........................................................ ................. 1

27 173515 SPACER FI NGER- nos .................................. 1
o o . . . . o o o o o o o o . . . . . . . o o . . o o o o o o o o . . . . . . . . o o . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . .
28 173434 SPROCKET CLUTCH ASSEMBLY .... 00 . . 00. . . .... . 1

. . . . . . . . . . o o o o o o . . . . . . . . o o o o oo o o . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . o o . . . . . . . . . . . .
29 180463 GUARD · Lower Sprocket 2

0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . . . . 0 0 0 0 0 0 . . . . . . . . 0 0 0 0 0 0 . . oo . . . . . . . . . . . . . . . . . . . . . . 0 0 . . 0 0 . . . . 0 0 0 0 0 0 . . . . . .
* = Not available separately

UNIVERSAL FEEDER
, - - - - - -1
~-- 2
6
19
7
19
5 5
8 9
-,_
',_
''-,,,,
,_
-,_ ~- 10
''......., ... 11
~; \ ---,,,__'--,,,__ /
12
8 8- - -c-----
0( t ------- ~-~ --c-•• ··- 1/'IF-----1
3~ 13 (
_____...,;,-- 18
14
15 _____..____
I
16 - "
---'- / /
"------

UNIVERSAL FEEDER
PAPER GUIDE RAIL CRANKS
Index Part
1 102410 SCREW - Hex Flange, 5/16-18 x 1" .•. oo ...•...• oo ••.••• oo .....•.••.••..•••..• oo •• oo •.. oo •.••oooo•··· ..•.•••••. oo ··oo··········..•. 4
2 150086 LOCKNUT ooooooooooooooooooooooooooooooooooooooooooooooooooooooo .. oooooooooooooooooooooooooo ooooo oooooooooooooooooooo oo .. oooooooooooooooooooo .. 4
3 039642 RING - Rubber ooooooo ••oo.ooooooooooooooooooooooooooooo 000000 0000 0000000000000000000000 0000 0000 0 2 00 00000 00000000000 00 . .00 0000 0 0000000000000000
4 025205 WASHER - .324 i.d. x .562 o.d. oo.oooooooo oooo 00 oooooo ooooooooo.oooooo .. oo .. ooooooooooooooo.oooooooo
00000000 8 00 0 0000000000 . . . . . . . 00 • • 00
5 173303 SPACER oo ....... oo.oooooooooooooooooooooooo ..... oooooo•oo•oo .......oo.oooooooooooooooo oooooooooooooooooooooooooooo oooo•oo··•oooooo oo ........ oooo• 8
6 197009 PIN • Dowel ...... oooooo .... oo .. oo ..... ooooooooooooooo•oo· oo ...... oo .... ooooooooo ... oo.oooooooooo .. oo ooooooo .......... oo .. 2
0000000000000000000000
7 102582 SCREW -Hex Flange, 3/8-16 x 1"oooooooooooooooooooo ..oo .. oooooooooooooooooooo .... oooooooooooooooo .... oo .. oooooooooooo ......oo.. oo.. 4
8 172262 FEEDER BASE oo ..oooo
0000. oooo• oooo• oooo•
0000 0000 00 oo• oooo• oooo•
0000 oooo• oooo• oooo•
000000. 0000oooo• ..... oo• oooo• ....oo... oo• 1
000000 0000 0000 00
9 172263 FEEDER BASE oo ..oooo

0000. oo ........
0000 0000 . . 00000 00000 00 . . 00000 oo. oo.
00000 0000 0000 0 oo. oo.
0000 00 . . 1
000 00 00 00 . . 000000 . . 00. . . 00000 000000000 000
10 001064 RING - Retaining ooooooo•oo•ooooooooooooooooooo ooooooooooooo ..... oo.oooooooo. oooo .... oo ..... oooo•oo · 4
00 00 . . 0000 0000000 0000000000000000000000 000
11 196397 BUSHING ......oo····oo···oo··oo···oo········oo····· .. oo····oo····-·oo·····oo···· ·oo· ···· .. oo·····oo ·····oo·····oo·····oo······oo· •ooooooooo···· 4

12 001094 RING - Retaining oooo .... oo .. ooooooooooooooooooooooooooo ..... oo. .. oooo ... oo.oooo•oooo ...... ooooooo ..... oo.oooooooooooo oo oo .... oo ........ oooo• 4
13 172804 SHAFT - Paper Guide Adjustment .. oo .. 2
00 00 00 00000 . . 00 . ... . . 00000000000000000000 0000 00000 000000 00000000000000 0000 00 00 . . . . . . 00 . . 00 . .
14 172802 BRACKET- Shaft Adjustment oooo ... oo ... oooooo ..... oo ..ooooooooooooooooo ooooooooo••ooooooooooooooooooo oooo•oo•oo•oooooooooooooooooooo 2
15 191384 WASHER oo•oo·oo·············oo···oo·····oo······oo·oo····ooooooo ... oo .. oo.oo·····oo ·····oo·····oooo ooooooo··· ··oo···oooo·oo··oo· ··oo·oo········· 4
16 102322 SCREW- Hex Flange, 1/4-28 x 3/4" oooooooooooooo oo••oooooooooooooooooooooooo .... oooooooooooooooooooooooooooooooooooooo ....oo.. oooo 4
17 197194 SCREW - Special .oo .. oo. oooo. oooo• oo.... oo• oo• oooo• .oooo ..oo. oo ... oo oo.oo
00 . . oo ...
0000 oo.oo ..
00 00 oooo•oo•
00 00 000 00 02 0000 000000 00 0000 . 0000 0 00 0
18 173397 SPACER ... oo.. oooo ............ oo.·oo········oo····oooo ...... oo .. oo .. oo·····oo·····oooo ····oo·············oo·····oo ·····oo······oo···oo·•oooo····· 2
19 172356 GUIDE FEED TABLE oooooooooooooooooooooooooooooooooooooo oo ooo oo ... oo .. oooooooooooooooooo ... oo ... oooo ooooooooo .. ..oo. oooo oooooooooooooooo 2
20 102410 SCREW. 5/16-18 X 1" ....................................... .. .......... .......................................... ....................... 8
21 017595 CRANKARMASSEMBLY oooooo•oooo•ooooooooooooooooooooooo•oooooooooooooo•oooooooooooooooooooooooooooooo ooooooo•ooooooooooooo•oooooo•· 2
22 102322 SCREW· Hex Flange, 1/4-28 x 3/4" .............. .................................................................................. 4
23 005071 WASHER oooo•·oo·········· ·oooo···oo·····oo······oo·oo····ooooooo ... oo ..... oo ..... oo ..... oo ..... oooo •oo··oo·····oo···oooo ..... oo ... oo.oo········· 4
24 005071 WASHER - .253 i.d. x .500 o.d. ooooooooooooooooooo ...... .......... oo .. oo ..........
0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 OOOOOOOO o o OOOOOO 4 00 . . .
25 172621 STOP TABLE - nos oo

0 0 0 . .. . . . . . . . oo ......... 1
0000 00 00 . . 00 00 . . 00 00 . . . . 00 . ... . . . . 00 . . . . 00 00 00 . . 00 00 . . . . . . . . . . . . . . . . . . 00.00 . . 00 . . 00 000000 . . 00 00.
26 172620 STOP TABLE- OS ooo .. ooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooo oooooooooooooooooooo 1

UNIVERSAL FEEDER
8 , 9, 10,
~-3
12
17--'
19---1
18 - - - - J

UNIVERSAL FEEDER
CAM ASSEMBLY AND EMERGENCY STOP SWITCH
Index Part
1 172174 TUBING - Vinyl, 025 iod ox 037 Oodo x 3/8" (sold 3') oo oooo oooooooooooooooooooooooooooooooooo oooooooo oo 00000000000000000000000000 1
2 178402 TUBING- Natural, 0375 i.dox 0500 Ood ox 3/8" (sold 3') 000000 0000000000 000 ............ .... ........... .................... 0 1
3 172149 SHAFT - Doubles Diverter 00000000000000000000 00000000000 0000000000000000000000000000000000 0000000000000000 000000 00000000000000000000000 1
4 172145 ROLLER GEAR ASSEMBLY 00 o.oooo .ooo 00 oo. 000000 .ooo0..000 oo.oo .ooo 000000 0000 .. 0000 oooo. 0000 000000 00000.. oo. 00 OOoooo. ooooooo.oo 00 .. oo 1
5 178723 SHAFT - Cam ooooooooooooooooooooooooooooooooooooooooooooooooo oooo oooooooooooooooooo oooooooooooooooooooooooooo•oo oooooooooooooooooooooooooooooo 1
6 173107 STUD 000000000000000000000000000000000000000000000000000000000000000000000000000000 00000000000000000000000000000 0000000000000 00 0000 00000000000000000 1
7 102268 PIN- Dowel, 01877/01875 0000000000000000000000000000000000000000000000000000000000000000000000000000000000 0000 0000000000 0000000000000000 2
8 254766 SWITCH - Push Button Activator 0000 0000000000 00000000 00 00000 000000 0000 00000 000000 00000000000000 0000000000 00000000000000000000000000 1
9 254765 SWITCH - Toggle 000000000000000000000000000000000000000000000 000000000000000000 00000 0000000000000000000000000 000000000000000000000000000000 1
10 187235 BRACKET- Stop Switch oooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooo oooooooooooooo oooooooooooooooo 1
11 101626 SCREW- 1/4 -28 X 5/8 " 00000 0000000000000000000000000000000 ..000000000000000000 00000000000000000000000000000 00000000 00 000000 000000000000000 4
12 001731 WASH ER- Lock, 0250 iod ox .485 Oodo 000000000 .. 0000 000000000000000000 .. 00 oooooooooooooooooooooooooo ooooooo .. 000000000000000000000 5
13 178806 PULLEY oooooooooooooo ooo oooooooooooooooooooooooooooooooooooooooooo..ooooooooooooooooooooooooooooooooo oooooooooooooooo oooooooooooooooooooooooooo ooo 2
14 172778 SPACER OO OOO OO OO OOOOOOOOO OO OOO OO oO OOO OOOOOOO OOO OOOOOOOOOOOOOOOOOOOOO OOOOOOOOOOOOOOOO OO OOOOOOOOOOOOOOOOOOOOOOOOOO OO OOOOOOOOOOOOO OO OOO OOOOOOOOoOOOO1
15 101626 SCREW - 1/4·28 X 5/8 " 0.... 000 00 00000 .......... 000000000...... 00000000000 00000 000000000...... 00000ooOOO .... oooooooo .. ...... 000000000000 0.. 6
16 001731 WASH ER- Lock, 0250 iodo x .485 Oodo 00000000 0000 0000000000 oooooo ooooooooooooooooooo oooooooooooooooo oo oo 0000000000 0000000000000000 6
17 178449 CAM - Feed Raise 00 000 000 00 00 00 00 00 00 00000 00000000 00 000 00 00 00 000 00 00 0000 000 00000 00 00 00 00 .0000 00 00 0000 000 00 00 00 000 00 .o00 000 00 00 0000000 00 0000 1
18 178450 CAM - Feed Forward 00 000000 00000 00000 00000 0000 00 0000 0000 oo ..oo 000000 00000 0000 0000000000 000000 00000 0000 .. 00. 00000oo ... 000000 000000000000 000 1
19 173457 HEADER- Hub Assembly oooooooooooooooooooooooooo ooooo..ooooooooooooooooooooooooooooooooooooo ooooooooooooooooooooooooooooooooooo.. oooo 1
20 197178 KEY oooooooooooooooooooooooooooooooooooooooooooooooooooooooooooo oooooooooooooooooooooooooooooooooooooooooooooooooooooooo oooooooooooooooooooooooooooo 1
21 102374 SCREW - 1/4-28 x 5/16" 00000000 0000000000 00000000000000 0000000000000000 0000 0000000000 00000000000 0000000000000000000000000000000000000000 2
22 001832 NUT- 1/4-28 oooooooooooooooooooooooooo ooooooooooo oooooooooooooo oooo oooooooooooooooooooooo ooooooooooooooo ooooooooooooooooooooooooo ooooooooooooooo 1
23 178805 SPACER 00000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000 0 1
24 178801 PLATEASSEMBLY oooooooooooooooooooo ooooooooooooooooooooooooooooooooooooooooooooooooooooooo oooooooooooooooooooooooooooooo oooooooooooooooo 1
25 191384 WASHER - 0260 i.do x 0750 oodo 00 00000000000000000000 0000000000000000000000000000000000000000000000000000000 000000000 00000000000000000 2
26 001731 WASHER- Lock, .250 i.dox .485 Oodo 000000000000000000000000000000000000000000000000000000000000000 00000000000000 0000000000000000 2
27 014157 SCREW- Hex, 1/4-28 x 1-1/4" oooooooooooooooooooo ooooooooooooooooooooooooooooooooooooooooooooooooooooooooo oo oo oo ooooooooooooooooooooo 1
28 101626 SCREW - 1/4-28 x 5/8" 0000000000 000000000000000000000000 00 ..00000000 0000000000000000000 .oo.oo 0000000000 0000 .. 000000 .. oo•oo· 000000000000000 1
29 186409 IDLER - Take Up oo oooOoooooooo oooooooooooooo oo oooooooooooooooooOOoooooooooooo ....... oo.oooooooooooo .. ooooo oo ... oo ... oooooooooo oooooooooo OOooo 1
30 001094 R ETAI NINGRINGoooooooooooooo ooooooooooooooooooooooooooooo oooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooooo ooooooooooooooo 1
31 190394 SPACER ooooooooooooooooooooooooooooooooooooooooooo oooooooooooooooooo ooooooooooooooooooooooooooooooooooooooooooooooooooooooooooo oooooooooooooooooo 2

UNIVERSAL FEEDER
24------
23- - - ---...
22 ~
~
19, 20, 21- - - - - -
16- - - - -
---14
..___ _ _ _ _ 15

UNIVERSAL FEEDER
DOUBLES DIVERT ASSEMBLY
Index Part
1 178728 PLATE ASSEMBLY· Diverter ............................................................ ........... ..... ............................. 1

2 001060 RING - Retaining ..................................................................................................... ................. ...... 1
3 021150 WASHER- .254 i.d. x .625 o.d. ...................................................................................... ................. 1
4 192035 SPRING ...... ....... ................ .... .......... ...... ..... ..... ..... ..................... ..... ......... ........... ........................ ..... 1
5 021150 WASHER - .254 i.d. x .625 o.d ....................... ............... ..... ......................... ................... ................. 1
6 197086 PLATE - Nut ................................................ ..... ..... ........................................ ................................... 1
7 197143 WASHER- Rubber .......................................................................................... ............................... 1
8 021150 WASHER - .254 i.d. x .625 o.d ........ ...... ......... ... .. ............... ......... ................ ..... ............................... 1
9 001060 RING - Retaining ............................................................ ..... ............... ..... ..... .... ............................... 1
10 178730 LINK - Solenoid ............................................... ..... ............................................. .... .......................... 1
11 014515 RING - Plastic ................................... ..... .................... ..... .......... .... ........... ..... ................................... 2
12 192034 PIN - Solenoid ...................................... ...... ..... .......................... .... ............... ............ .. ..................... 1
13 100529 SCREW - 4-40 X 3/8" ............................ ................ ........................................ .... ........ ....................... 4
14 192795 WASHER - Lock ................ .............. ..... .......... ........... ..... ..... .... ................ ..... ................................... 4
15 180980 SOLENOID ASSEMBLY· Doubles Divert ..... ........... ..... ..... ..................................... ....................... 1
16 178731 BRACKET- Solenoid Support ........................... ............................................................................ 1
17 197345 PLATE- Nut ....................... ............... .......... ..... .......... ................ ..... ......... ..... .................................. . 2
18 100653 SCREW · Cap, 1/4-28 x 3/4" ................ ............ .. ...... ..... .... ..................... .... .................................... 2
19 100137 NUT- Hex, 2-56 .......................................... .................... .............................. ..... .............................. 2
20 100138 WASHER- Lock ................ ................... .......... ........... .......... .... ................ ..... ................................... 2
21 110002 SCREW . 2-56 X 5/16" ..................... ..................... ..... .............................. .... ..... ........ ... .................... 2
22 150050 NUT- 1/4-28 ...................... .... ........... ..... ......... ...... ................ .... .................... ..... .............................. 1
23 197088 STAND OFF - Pivot, os ...................... ............. ............ ......... ............... ..... ........................................ 1
24 0 14504 RING - Snap .................... ............................... ........... ..... ............................. ..... ............................... 1
25 197087 STUD ................................................ ..... ......... ............ .... ..... ............... ..... .... ..... ............................... 1

UNIVERSAL FEEDER
33- - -·
~---30
32----
' - - - - 31
2--
3
1 6, 7, 8
4--~J.:t::jn~J
5-------=~~ .---9
.---34
!l
l
l
l
l
l
I
l
.....~...... )
6'" . . . .,.,
'..x:'l
/
I
/l'
, I
I
I
I
I
I
'-----15
---17

UNIVERSAL FEEDER
AIR AND VACUUM CONTROL VALVES
Index Part
1 014327 SCREW- 10-32 X 1/2" .................................................................................................................... 1

2 180960 MOUNT · Gauge Registration ............................................................................................. ............ 1
3 180780 ELBOW - 90 Degrees x 3/8" ........................... ................................................................................ 1
4 180778 ELBOW - 90 Degrees, Street .......................... ..................... .... .... ................................................... 1
5 180835 PLUG- Loctite .................................................. .......................................... ............... ..................... 1
6 101999 SCREW . 10-32 X 1/2" .................................................................................................................... 1
7 021861 WASHER- .196 i.d. x .437 o.d......................................................................... ............................... 1
8 150083 NUT - Lock, 10-32 ......................................... .............................................. ............ .. ..................... 1
9 032868 PIN - Roll .................................................... .......... ................ .... .................................. ..................... 6
10 014158 SCREW - 10-32 x 1/2" ............................................................ ................................. .. ..................... 9
11 000666 WASHER- Lock, .198 i.d. x .334 o.d....................................................................... .. ..................... 9
12 179815 BARB - 10-32 x 1/16" .................................................................................................. .................... 1
13 178407 TUBING- Clear, .063 i.d. x .125 o.d. x 3" (sold 31') ................ ................................... .................... 1
14 180961 GAUGE - Vacuum ....................................... ..................... ......... ....................................................... 2
15 180772 BODY · Valve ................................................................................................ ............ .. ..................... 1
16 101876 PIN - Roll ......................................................................... ..... ........................ .............. ..................... 3
17 180776 ELBOW ASSEMBLY- Loctite, 90 Degrees .... .......................... .... ................................................... 1
18 180775 ELBOW · Loctite, 90 Degrees x 5/8" ............................................................... ........ ....................... 4
19 180774 SPOOL - Feeder Valve ................................................................................................................... 1
20 180773 SPOOL- Valve .......................................................... .............. ......................... ........ .. ..................... 2
21 180959 MOUNT · Gauge Feeder ........................................... .............. ........................................................ 1
22 180782 PLATE- Valve ................................................. ........... ........... ..... ............................... .. ..................... 1
23 197326 SPRING - Compression ............................ .... ................................................................................. 3
24 102184 RET AI NING RING- Black .............................................................. ........................... .. ..................... 3
25 101626 SCREW - 1/4-28 X 5/8" .......... ............................... .......... ..... ......... .............................. ..................... 2
26 001731 WASHER - Lock, .250 i.d. x .485 o.d..... ........... .. .................................... ........................................ 2
27 180783 GUI DE - Nut ...................................... ........ ........ .................. ............... ...................... .. ..................... 1
28 172812 RET AINER - Nut ................................... ...... .... ...... ..... ...... ..... .... ....................................................... 1
29 180472 KNOB ................................ ............... .... ........... ..... ........... .... ..... ...... .......................... ....................... 4
30 197387 NUT - Square ................................................. ........................... .... ........................... .. ..... ................ 2
31 001726 WASHER - Speed Cli p, .258 i.d. x .438 o.d. ............ ....................................................................... 1
32 178775 SPRING - Compression ....................... ......... ................ ...... .... ..... .................................................. 1
33 180771 RELIEF VALVE- Vaouum ... .... .................... ..... ..... ..... ..... ..... ...... ..... ......... .......... ...... .... .... ................ 1
34 01 4158 SCREW ............. ................................................... ........................................................................... 7

UNIVERSAL FEEDER
6, 7, 8, 9, 10, 11 - - - - - - - -
~-- 25
1, 2, 3, 4 - - - - - --
5 -----------...
~~~.
~---- 13, 7, 8,
16 9, 10, 11
'------- 27'
19, 20-....J
- - - - 28:
...___ _ _ _ 29
' - - - - - - - 30
2 2 - - - -....J

UNIVERSAL FEEDER
HEADER TUBE ASSEMBLY
Index Part
1 172229 BAR - Feeder Tie .............. .............. ................ .. ................. ...... ..... ......... ......................................... 1
2 190129 SCREW. 5/16-18 X 1/4" .............................................................. ..... ........... .... ............................... 2
3 197054 BOLT · Shoulder, 5/ 16·18 x 3/8" ...... .... ......... ..................................................................... ............ 2
4 001750 WASHER · .338 i.d. x .562 o.d........ ............... .... ............................................................................. 2
5 178720 BAR · Lower Tie .................................... ............... ................ ............................. .............................. 1
6 172357 BRACKET· Feeder Mounting ......... ..... ......................... ............... ............................ .. ..................... 1
7 102220 SCREW · Shoulder Bolt, 3/8" x 3/4" ...... .................... ...................................................................... 1
8 100653 SCREW · Cap, 1/4-28 x 3/4" ............ .... ............ .. ........... .... ................ ............................................. 1
9 001731 WASHER · Lock, .250 i.d. x .485 o.d................................................................ .............. ................ 1
10 150086 NUT · Lock, 5/16-18 ....................................... ........... ...................................................................... 2
11 190129 SCREW . 5/16-18 X 1/4" .................. ............... .......................................................... .. ...... ............... 1
12 102166 PIN · Taper ..................................... ................ .. ... ............... ............................................................ 2
13 172358 BRACKET - Feeder Mounting ......................................................................................... ................ 1
14 172355 BRACKET· Feeder Mounting ......... ............................... ..... ............... .............. ........ .. ..................... 1
15 172354 BRACKET· Feeder Mounting .............. ..................... ..... ..... ......... ...... .............. ........ .. ..... ................ 1
16 102130 SCREW • 3/8-24 X 1" ............................................................................................. .......................... 2
17 001936 PIN ·Taper ....................... ................................... ............... .............. ................ ............................. . 1
18 172210 HANGER ASSEMBLY .................... ................... ... ..... ........................ .... ..................... ..... ................ 1
19 102354 SCREW . 3/8-24 X 9/16" ................................................................................................... ............... 4
20 001763 WASHER · Lock, .385 i.d. x .673 o.d ............................................................................................... 4
21 197148 BUSHING - Oilite ............................................... .. ..... ......... ................ .............................. ............... 2
22 001073 RING • Retaining ................... ......................................... ......................... ......................... ............... 1
23 014510 "E" RING ........................................................................................................................... ............... 2
24 178607 SHAFT ASSEMBLY .. ....... ............... ............... .... ................. ......... ..................... .... ......... ...... ......... ... 1
25 197160 COLLAR SHAFT ............................................. ................................................................................. 1
26 178403 TUBING· Clear, 3/8 i.d. x 5/8 o.d. x 17" (sold 15.5') ............................................ .......................... 1
27 197182 BARB - Male Connector .................................. ................ .............................. .... ............... ... ............ 1
28 178881 TUBE · Sucker ................................................ ...................... .... .................... ..... ............................. 11
29 178932 CUP - Feeder Sucker ........ .................................... .... .......... ...... ........................ .......... .... ............... 11
30 173368 HEADERTUBEASSEMBLY ............................................................................................................ 1
31 150085 NUT · Lock, 1/4-28 ......................................... .......................................................... ....................... 1
32 178603 LEVER - Feed Forward Assembly ............................ .............................. ................... ..................... 1
33 197451 TRACK · Roller .875 ........................................................................................................................ 1
34 102163 SCREW · Cap, 1/4-28 x .437 .......................... .................................. .................... .. .. ..................... 1
35 172967 DECAL .............................. ..... .......... ............... ................. ......... ............... ..... .................... ............... 1
36 111054 SCREW - Hex, Washer Hd ............................ ................................................................................ 1
37 173130 BRACKET ....................................... ................ .. ... ..... ......................... .... ................ .... .... ................. 1

UNIVERSAL FEEDER
7
8
43 '
42
41
39, 40
36
37
29-----
' - - 22
24 ------..J '---21
23 - - - - '

UNIVERSAL FEEDER
PULLOUT ROLLERS
Index Part
1 001683 SCREW ........................................................... ................................................................................ 2

2 180690 SPRING - Detent .............. ................ ..... ................................... ............... ..... ................................... 2
3 190130 SCREW- Set, Nylok, 6-32 x 1/8" ...... .... .................................................................... ....................... 2
4 180691 HOLDER - Spring ............................................ ................................................................................ 2
5 001710 WASHER- Lock, .320 i.d. x .570 o.d .............................................................................................. 1
6 001840 NUT - 10-32 ........................................... ..... .... ...................... ..... ......... ............................................. 1
7 180688 KNOB - Upper Roller ...................................... ............................................. ................................... 2
8 180687 SPACER - Upper Roller ................................. .......................................................... ....................... 2
9 100653 SCREW - Cap, 1/4·28 x 3/4" ............ .... ..................................................................... ..................... 2
10 102371 SCREW. 10·32 X 5/16" ......................... .......... .......................... ......... .......... ............ ....................... 2
11 172737 LABEL - Feed Roll, nos .................... .... ......... .................................................................................. 1
12 172736 LABEL · Feed Roll, os ........................... ..... .... ................................................................................. 1
13 197011 SPRING - Compression .. ..................... ................................... .................... ................................... 2
14 021203 WASHER- .254 i.d. x .500 o.d ....................... ................................................................................. 2
15 197158 BEARING - Spherical ...................... ........... ..................................................................................... 4
16 172246 CLIP - Bearing Retainer .... ............................................................................................................. 4
17 173716 ROLLERASSEMBLY ...................................................................................................................... 4
18 001992 PIN - Roll .......................................... ........................................ ....................................................... 1
19 172207 ROLLER SUPPORT ASSEMBLY ..... ............................................................................................... 1
20 100998 WASHER · .195 i.d. x .438 o.d.............. ............ ........................................................ ...................... 1
21 014504 RING - Snap .................................................................................................................................... 1
22 172203 LEVER SHAFT SUPPORT ASSEMBLY- os .................................................................................... 1
23 172539 LEVERASSEMBLY ......... ................ ..... ..... ....................................................... ....... .. .................... . 1
24 192258 WASHER .............................................. ........................................................ ................................... 2
25 001710 WASHER- Lock, .320 i.d. x .570 o.d . .... ...................................... .............................. ..... ............... . 1
26 001840 NUTANDWASHER - 5/16-18 ............... .......... .............................. .................................................. 1
27 014504 RING - Snap ..................... ................ ............................................................................................... 1
28 100998 WASHER - .195 i.d. x .438 o.d ................................................ ........................................................ 1
29 172123 SHAFT - Roller Support ................................................................................................................... 1
30 172220 STRAP- Guide ................................. .................... ........................................................................... 4
31 001721 WASHER - 380 i.d. x 625 o.d ........ .................... .......... .................................................................. 2
32 172202 GUIDE- Stud .......................................................................................... .... .................................... 2
33 003560 COLLAR ........................... .......................... .... ...... .......................................................................... . 2
34 014372 SCREW - Set, 10-32 x 1/4" .............. ..... ..................................................................... ..................... 2
35 172513 LEVER - Shaft Support ............................................................ .................................. ..................... 2
36 172204 LEVER SHAFT SUPPORT ASSEMBLY - nos ...................... .......... ..... .......... ................................... 1
37 192258 WASHER- .381 i.d. x .562 o.d ........ ................................................................................................ 2
38 197157 BEARING- Thrust ........................................................................................................................... 1
39 172209 SUPPORT ARM - OS . ......... .............. ..... ........... ..................... .......... .... .......... ...... ...... .. ..................... 1
40 172208 SUPPORT ARM - nos ............................ ..... ....................................................... .............................. 1
41 197219 RING - Retaining ..................................................................................... ................. .. ..................... 1
42 197159 BEARING - Spherical ..................................... ................................................................................. 2
43 079764 CLAMP - Plastic Cable .................... ..... ........................................................................... ................ 2

UNIVERSAL FEEDER
1 - ---
2- - - -
. _ - - 13

UNIVERSAL FEEDER
VACUUM TIMING SPROCKET
Index Part
1 101626 SCREW- 1/4-28 X 5/8" ............................................................... ._ ................................................... 2

2 001731 WASHER- Lock, .250 i.d. x .485 o.d .............................................................................................. 2
3 178678 SPROCKET - Vacuum Timing ....................................................................................................... 1
4 178676 SPACERASSEMBLY ..................................................................................................................... 1
5 180840 DISC ASSEMBLY - Port .................................................... .... ...... ._ ................................................... 1
6 001731 WASHER- Lock, .250 i.d. x .485 o.d ............................................ .................................................. 2
7 100339 SCREW- Cap, 1/4-28 x 318" ...................................................... ._ ................................................... 2
8 180794 VALVE - Manifold ........... .................................................. .... .......... ......................... ..................... ... 1
9 197182 BARB - Male Connector ....................................................... ..... ._ ... .... ......................... ................... 1
10 001073 RING - Retaining ....................................................................... ._ ....................... ............................ 1
11 197078 WASHER -Thrust, 3/4" i.d. x 1-1/4" o.d................................ .......................................................... 1
12 180775 ELBOW - 90 degrees x 5/8" ............................................................................................. .............. 1
13 102374 SCREW- 1/4-28 x 5/ 16" ........................ .................................... ._ ................................................... 1
14 180793 DISK - Port ....... ................................................................. ............................. .... ................ ............. 1
15 197337 BEARING· Sleeve ........................................ ..... .......... ..... ............... ............................................... 1
16 180792 PLATE - Timing .............................................................................................................................. 1
17 197338 WASHER - Curved Spring ........................................... .... .............................. ................................. 1
18 102359 SCREW - Phillips, 8-32 x 3/8" .......................... ......................... ._ .... ............................................... 4
19 197077 WASHER - Curved Spring ............................ .................................................................................. 1
20 178670 SHAFT • Vacuum Idler .................................................................................................................... 1
21 102325 SCREW - 3/8-24 x 7/8" .................................................................................. .......... ....................... 1

UNIVERSAL FEEDER
1 - - - -.. . .
NOS ~------ 3
4
6
5
7
4
6

UNIVERSAL FEEDER
SPROCKET ASSEMBLY- PART 1
Index Part
1 180635 GUARD ASSEMBLY · nos 0 00 00 00 000 0000 00 00 00 00 000 0000 000 00 00 0000 00000 00000 000000 00 000 0000 00000 0000 0 0000 00 00 00 0 0 00 0000 00 0000000 00 000 00 0 1
2 180613 GUARD ASSEMBLy. OS oo o oo ooo oooooooo oo oo ooo oo ooo oooooo o ooo oo oooo oo ooooooooooooooo o oooo oo ooooooooo oo oo oooo oo oo 0000 0000 00 00000000 00 00 0 1
3 101676 SCREW. 10-24 X 3/4" o oo oo oooo ooooooo oo ooo oo oo oo oooooooo oo oooooooooooooooooooooooooo oo ooooo o ooooooooooooooooo oo ooo oo oooooooooooooooooo oo o 4
4 180908 SPROCKET ASSEMBLY 00 00 000 o . ooo 00 0000 0 0000 0000 0000 0 00 0 0 oooo . . . oooo 0000 . . oo • • • oo o ooooo . oo oo . 00000 0000 . . oo. 000 00 00 0000 oo • • oo . oo 000 00 0 4
5 001048 RING • Retaining ooooo o oooo oo oooooooooooo oo ooooooooooooo oo oo o o o oo o o o o o o o o o o o o o o o o o o o o o 0 0 0 0 0 0 0 0 0 0 0 0000000000 00 00 0000 0 000 00 00 00 00 00 00 000 00 000000 8
6 180910 BLOCK • Support 0 00 00 00 00 00 00 0 00 000 00 00 0 0000 0000 0 00 00 00 00 . . 0 000 0 0 0 0 0 0 0 0000 0 00 000 00 00 00 00 00 0 00 00 00 00 0 00 00 0 00 00 00 00 00 0 0 .. 0 00 00 00 00 0000 00 00 0 00 0 2
7 102186 SCREW • 3/8-24 x 1" 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 4
8 000024 PIN ·Taper 00 00 00 0000000 00 0000 00 000000000000 00 0000000000000 000 00 00 0 000000000000000 00 00 000 000000000 0 0000000000 00 00 00 00 0 0000 0 0000 00 00 00 000 00 000000 4
9 180626 SPACER · Chain Guard o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o OO o o oo o o o o o o o o o o o o o o o o o o o o o oooooooo oo o oo oo o ooooooo . . oo. oo . . . oooo . . . oooo . . . .oo. . oooo 2

UNIVERSAL FEEDER
1
2
8
'-----11
' - - - - -12

UNIVERSAL FEEDER
SPROCKETASSEMBLY-PART2
Index Part
1 180678 MOUNT - Spring Guide .... ................ .... ....................................... o ••• o ••••••••• •• •• ooo •••••••• • •••• oo •• o• • •• ••• ••• o. 1
2 180653 SCREW - Knurled ···-························································································· ······························ 3
3 180831 MOUNT · Spring Guide .... · o· ·· ••• •• o••••• • ••• ·o··· o ••••••.• o •••••••••••• ooo •••••••••• o ••• o ••••••••••••• oo o ••••••• · o···· o· ••••• •• ··o ·•· o· 1
4 180832 SCREW- Spring Guide, 1/4-28 x 3/8" .. ..... o •••••• •o······ •••••••• o•••••••••• o •• oo•········· · ···· o·· · · ••••• •••• o••••••••• •••• • •• 1
5 102392 SCREW - 6·32 X 3/8" ........................ .... ..................... ..... .... ................ .......... .... ........ ....................... 2
6 102391 SCREW- 8·32 X 1/4" ........................ .... .... ····· ····• o•••••••••• • •• o•••••• ••• •• ooooo • ••••••••••••o•••••• ••• • • •• ooo•• · · · ··· ·· ······ 2
7 180675 BRACKET- Rear Blower ................................ ...... .... ...................................................................... 1
8 180674 HOLDER - Rear Blower .... ................... ......... .....o• •• • •• ••• • • •• oo •• •••••• •• 0 ••• 0 •••••••••• • •• oo • •• •• •••• • ••••
0 1
•••• •• •• ••• • • • • •
9 178341 SPRING - Plunger ................................. ............... ........................................................................... 1

10 186132 HOLDER - Spring ............................................ ..... ........................................................................... 2
11 101612 SCREW . 1/4-28 X 7/16" ... ............... ......... ..... ............ ......... ................ .............. ........ .. ...... ............... 3
12 173507 PLATE · Guide .... .............. ................................................... ............................................................ 1
13 180672 BLOWER - Rear, nos ........ .............................. .................... .............................. .............................. 1
14 180830 HOLDER - Spring .............. ................... ........... .......... ........... ........ ................ ................... ................ 1
15 084283 KNOB ................. .................. o . .. .. o.. ... . .... . o... .. ... ... .. ... .. ... ... . ... ... .. ... . .. .. .. . ... . .. ... .. .. . ..
0 ... ....... . .... . 1
.... .. .. .. .
16 172329 GUI DE - Spring .................................................... .......... ................................................................. 1

17 001744 WASHER- 11/64 i.d. x 9/32 o.d ..................... ... ................................................ ....... .. .................... . 2
18 190345 WASHER - .170 i.d. x .293 o.d ........ ................................... ............................................................. 2

UNIVERSAL FEEDER
11
17
21
22 _ _/ 18 ----12
23 ~ 1
~

UNIVERSAL FEEDER
PAPER FEED GUIDES
Index Part
1 178634 SHAFT· Pivot ..... ............................................. ......................................................... ....................... 1

2 014165 SCREW • 1/4·28 X 1" ........ ............... ..... ............... .......... .............................. .... ............................... 1
3 196891 CLAMP • Collar ................................. ..... ......... ................................................................................. 2
4 178627 BAR · Stack Guide Pivot ... ..... .......... ..... ........................................................ ............... .................... 2
5 001833 NUT · 1/4·20 ............................................... .......................... ............................. .............................. 1
6 102358 SCREW· Set, 1/4-28 x 1/4" ............. ..................... .......................................................................... 2
7 178629 SHAFT • Side Adjustment Support ................................................................................................ 1
8 180842 BRACKET· Clamp .......................... ......... ........ ................................. ......... .... ........... ..................... 1
9 100625 SCREW · 1/4-28 x 1/2" .................................. ...................... ............................................................ 1
10 252094 CLAMP • Cable ............................................... ..... ........................................................................... 2
11 073385 BRACKET· Clamp .......... ................ .... ..... ........ .......................................... ............... ..................... 1
12 178341 SPRING · Plunger .......................................... ..................... ......................... .... ........ .. ..................... 1
13 073394 SCREW · Knurled ...................................... ..................................................................................... 3
14 102323 SCREW· Set, 1/4-28 x 3/4" ................................................ .............................. .............. ................ 1
15 172900 BLOCK • Plate Support .............................. ......................... ......... ................ ............ .. ..................... 1
16 180673 BLOWER · Rear, os ....................................................... .................... .............................. ............... 1
17 014158 SCREW. 10·32 X 1/2" ................................... ... ......................................................... ..................... 4
18 178628 BAR · Stack Guide Pivot ................................ .................................................................................. 1
19 173106 SCREW · Special ............................................................................... ............... .............................. 1
20 173104 LATCH ASSEMBLY ........................................ ................................................................................ 1
21 007689 GUIDEASSEMBLY · Back ................ .......... .... ................ .... .............................. ....... .. ...... ............... 1
22 073467 BRACKET· Back Gu ide ........................... ..... .......................................... ........................................ 1
23 072292 NUT · Knurled ................................................................................................................................. 1

UNIVERSAL FEEDER
1- - - - - - , 4
~-------9
10

UNIVERSAL FEEDER
HOLD DOWN STRAPS
Index Part
1 178721 BAR· Upper Tie .............................. ................................................................................................ 1

2 102374 SCREW - 1/4-28 X 5/16" ... ................................................................. ..... ..... .... ..... ... ....................... 1
3 172720 LEVER - Stop ..... ................... ................................................................................... ....................... 1
4 072304 SCREW -Shoulder ............................................. ..................................................... ....................... 1
5 193577 SPRING -Washer ............................................................... ......................... .... ............................... 4
6 173350 SCREW - Knurled ................................................ .................... ............... .......... .............................. 4
7 180646 SHAFT- R.H. Assembly ... .................................... ........... ............................. ................................... 2
8 180644 SHAFT - L.H. Assembly ....................................................... ...................................... ..................... 2
9 065361 SCREW -Thumb .............. ............................................................................... ....... .. ..................... 5
10 001106 SCREW- Phillips, 10-32 x 3/8" ....................... ............................................................ ................... 10
11 172236 BRACKET- Hold Down ................................... ..................... .................................... ....................... 5
12 172237 STRAP - Hold Down ............... ............................................. ..................................... ....................... 5

UNIVERSAL FEEDER
1---------
2------....
3-----
6 -----......
5------
7-----.
14
11

UNIVERSAL FEEDER
FEED LINK ASSEMBLY
Index Part
1 173448 STUD - Eccentric, Feed Forward .... ................................................................................................ 2

2 014703 WASHER - .384 i.d. x .562 o.d ... ..... ............................................ ................ ..... .............. ................. 1
3 173447 BRACKET - Feed Forward Lever ......... ...... ....................................... ...................... ....................... 1
4 001818 NUT· 1/4-28 .................................................................................................................................... 2
5 192797 WASHER- .263 i.d. x .489 o.d........ ...... ............ ............ .......... ........................................................ 2
6 173446 LEVERASSEMBLY ......... ..... .......................... .... ................ ..... ....................................................... 1
7 178841 LEVER ASSEMBLY ......... ..................... .......... .. .. ........... .......... .... ................ ............ .. .................... . 1
8 197127 WASHER -Thrust ...................................................... ..... ..... .... ..................... ............ .. ..................... 1
9 001094 RING • Retaining .............. ................ .............................. ..... ..................................... .. ..................... 1
10 021208 WASHER · .323 i.d. x .500 o.d.............. .............. .... ...... ..... ..... .... .................................................... 2
11 102163 SCREW· Button Head, 1/4-28 x .437 ............................ ............... .................................................. 2
12 197001 ROLLER · Track ............... ............... ..................... ..... ...... .... ..... .................... ................................... 2
13 150085 NUT· Lock, 1/4·28 ........... ..... ................ ......... ...... ...... .... ..... .... ..................... ................................... 2
14 173674 PIN - Feed Raise .............. .... ..................................... .... .......... ...... ................................................. 1
15 014807 NUT .................... ............... .... ..................... ......... ..... ..... ...... ..... ......... ............... .............................. 1

UNIVERSAL FEEDER
4
3
1-------,.
30
18
15
16
17
23 - - _ J

UNIVERSAL FEEDER
FEED SOLENOID
Index Part
1 172148 SHAFT - Follower .................. .......... ................ .............................. ................ .................................. 1

2 197126 WASHER- Thrust, .315 i.d. x .750 o.d.................................................. ...... ..... .............................. 1
3 001750 WASHER- .338 i.d. x .562 o.d .............. ......... ... .. ............................................................................ 1
4 001095 RING - Retaining .............. ..... ........... ..... ......... ...... ..... ................................... ................................... 1
5 178835 LINKASSEMBLY .................................. .... ..... ............ ..... .......................................... ....................... 1
6 178982 NUTPLATE ASSEMBLY ..... ............. ..................... .......... ................................................................. 1
7 102372 SCREW - Phillips, 8/32 x 1/4" ................................... ...................................................................... 1
8 001842 NUT - 3/8-16 ..................................... .......... .... ........... ...... .................................. .............................. 1
9 001763 WASHER · Lock, .385 i.d. x .673 o.d..... ........ ... .. ........... ................................................................. 1
10 197180 SPRING- Extension ............................................. .......................................................................... . 1
11 196901 PIN -Spring Anchor ....... ................... .......... .... ............ ..... .................................. .............................. 1
12 178881 TUBE · Sucker ................... ............... .............. ................. ............................................................... 11
13 178932 FEED - Sucker Cup ............................... ............... .......................................................................... 11
14 178847 STUD - Spring Anchor ... ..... .............. .......... ..... ..... .............................................. ............................. 1
15 021203 WASHER· .254 i.d. x .500 o.d ........ ............... ... .. .......... ..... ......................... ..... ............................... 2
16 102122 SCREW- 1/4-28 X 1/2" ................................................... .......................................... ······················· 2
17 014187 SCREW - Phillips, 8/32 x 3/8" .......... .............. ........... ..... ..... .............................. .............................. 2
18 178420 PLATE - Solenoid ....................................... .......... ..... ..... ...... .... ....................................................... 1
19 197140 SPRING - Extension ....................................... ................................................................................ . 1
20 172921 STANDOFF ........ ....................................................... ...................................................................... 1
21 253375 SOLENOID ......... ............................. .... ........... .. ... ..... ..... .......................................... .. ..................... 1
22 178418 PAWLASSEMBLY -Stop ....... ......................... .. ... ..... .... ................ ......... ..... .................................... 1
23 190713 PIN 1 ........................................................................ ..................................................................... . 1
24 001049 RING - Retaining .............................. .............. ........... ..... ..... ............... .......... .... ........ .. ..................... 1
25 014515 RING - Plastic ........................................ ............... ..... ..... ................................................................. 2
26 197126 WASHER- Thrust, .315 i.d. x .750 o.d .......................................................................................... . 1
27 001095 RING - Retaining ............................................ ........... ..... ..... ............... ...................... .. ..................... 1
28 196901 PIN - Spring Anchor ....... ......... ............... ..... .... ...... ...... ..... ..... .... .......... ...... ......... .............................. 1
29 173456 LEVER ASSEMBLY ......... ..... ........... ..... .......... .. .. ........... ..... ......... ................ ..... ............................. . 1
30 014157 SCREW- 1/4-28 X 1-1/4" ................. ................. ........ ..... .... ............................................................ . 1
31 001731 WASHER - Lock, .250 i.d. x .485 o.d ................ ....................................................... .. ..................... 1
32 197147 SPRING - Extension .......... ............................. ...... ..... ..... ...... .... ..... ............... .................................. . 1

UNIVERSAL FEEDER

UNIVERSAL FEEDER
FEEDER DRIVE
Index Part
1 190254 NUT- Hex ........................................................................................................................................ 1

2 001763 WASHER· Lock, .385 i.d. x .673 o.d.............................................................................................. 1
3 178813 STUD - Pivot ..................... ................... .................................... ......................... .............................. 1
4 178816 BRACKET ASSEMBLY -Idler ............................................................................ .... .......................... 1
5 197076 WASHER - Thrust .............. .... ..................................................................................... ..................... 3
6 178814 SPROCKET · Idler ............................ .......... ..... ..... ........... ..... .... .... ........... ..... ................................... 3
7 001094 RING - Retaining .................................................. ............... .... ........... .......... .... ............................... 3
8 197134 KEY · Timing Pulley ........... .... ................ ......... ................................................................................. 1
9 102322 SCREW - WI Flange, 1/4-28 x 3/4" ................. .. ...... .......... .... .......... ...... ........................................ 3
10 003855 WASHER· .256 i.d. x .500 o.d.......................... .. ............... .............. ............................................... 3
11 178812 SPACER ........................... ..... ........... ..... ..... ............... ...... ..... .... ............... ..... .... ................ ............... 1
12 178809 MOUNTING PLATE ASSEMBLY ..... .... ........... ... ................. .......... ..... ..... ..... .... ...... ..... ..................... 1
13 001771 WASHER· .385 i.d. x .875 o.d........ .................. .. .................... ......... ............................................... 1
14 102267 SCREW . 3/8-24 X 2· 1/2" .. ..... .......... .......................................................................... ..... ............... . 1
15 102374 SCREW · 1/4·28 x 5/16" ... ..... .......... .......................... ..... .... ................ .............. ............................... 4
16 191797 WASHER· .265 i.d. x .625 o.d........ ...... .......................................................................................... 3
17 001731 WASHER· Lock, .250 i.d. x .487 o.d .............................................................................................. 3
18 100653 SCREW · Cap, 1/4-28 x 3/4" ............ .... ...................................................................... ..................... 3
19 180529 CAM · Power Paper Feeler ........................ ..... ............................................. ................................... 1
20 172867 HUB- Drive Sprocket ........ .... .......... .......................... .......... ......... ................ ................... ............... . 1
21 178682 SPROCKET · Feeder ....... ..... ........................ ............................................................. ..................... 1
22 173454 GEAR · Drive ................. .......... ......... ..... ..... ..... ................................................................................ 1
23 197174 SPACER ................................ ........... ..... ..... ............... ............... ......... ...... ..... .... ............................... 1

UNIVERSAL FEEDER
16---
17 - -
18---
5, 6,7

UNIVERSAL FEEDER
FEEDER CONVEYOR ASSEMBLY- PART 1
Index Part
1 186408 BELT - Timing .................................. ........................................................... ................................... 1

2 178806 PULLEY ...................................................... ..... .................... .............. ............................................. 1
3 190394 SPACER .......................................................................................................................................... 1
4 172526 CONVEYOR· Plate ..................................................................................... ................................... 1
5 102345 SCREW . 10· 32 X 1/2" ..................... ........ ......... ................................. ...................... .. ..... ................ 6
6 000666 WASHER · Lock, .200 i.d. x .334 o.d ................ .. .............................................. .............................. 6
7 021861 WASHER- .196 i.d. x .437 o.d ........................................................................................................ 6
8 100339 SCREW · Cap, 1/4-28 x 3/8" ............ .... ......... ..... ...... ..... .... .......... ...... ........................ ..... ................ 1
9 191384 WASHER - .260 i.d. x .750 o.d .............. .... .................... .......... ........................................................ 1
10 172132 PLATE- Bearing Retainer .................................... ........................................................... ................ 1
11 197145 WASHER - Wave Spring .. ............... ......... ..... ............... ..... ................ .............. ............... ................ 1
12 080312 BEARING ........... ....... ....... .................... .......... ............ ..... .... .......... ...... ............................................. 2
13 000666 WASHER- Lock, .200 i.d. x .334 o.d .................. .............................................. .............................. 4
14 100339 SCREW- 10-32 X 1/2' ....... .................... .... ................. ..... .... .......... .................... ........ .. ...... ............... 2
15 102129 SCREW- 10-32 x 7/8" ..... .................... ............. ................................. ......... ............... ..................... 2
16 172496 BELT- Conveyor ................................. ........... ................... ..................... ........................................ 5
17 178722 SHAFT- Conveyor Drive .... ................... ............................................. ...................... ....................... 1
18 172131 HUB - Bearing Retainer .................................................................................................................. 1

UNIVERSAL FEEDER
5, 6, 7
14
15
16
17
......._____-18
........__19
.~~:: 20
........_-21
""'--- 23
26 L...------24

UNIVERSAL FEEDER
FEEDER CONVEYOR ASSEMBLY- PART 2
Index Part
1 178746 PLATE- Nut ..................................................... ................................................................................ 2

2 172244 BASE - Conveyor .............................. ........................................ ................ .... ................................... 1
3 178765 BRACKET - Pulley Adjustment ......................................................... ............................................. 2
4 172241 ROD- Hold Down ........................................................................................................................... 1
5 172245 BRACKET - Rod .......................................................................................... ..... ............................... 2
6 000666 WASHER - Lock, .200 i.d. x .334 o.d..... ............. .............................................. .............................. 4
7 102345 SCREW - 10-32 X 1/2" ..... .................... ............. .......................................... .................................... 4
8 072292 NUT - Knurled ...................................................................... ........................ ................................... 2
9 015118 WASHER- Friction ............ .............. ............... .............................. ............................ .. ..................... 2
10 016572 WASHER - .255 i.d. x .875 o.d........ ...... .......................................................................................... 2
11 172619 PLATE ........................................................................................... .................. ................................ 1
12 186413 RETAINER - Bearing, os ..................................................... ..... .......... ............................................. 1
13 186415 HOUSING - Bearing .............. .......... .... ..... .................................... ................ ................................... 2
14 197145 WASHER- Wave Spring ................................................................................................................ 2
15 080312 BEARING ......................... ................ ............................................. ...... ............................................. 2
16 178761 PULLEY - Crown ............... .... ................ ............................................................................. ............ 2
17 178737 PULLEY - Crown ............................................................................................................................. 3
18 197410 SPACER- Pulley ........................................ ..................................................................................... 2
19 178767 HANDLE · Pulley Adj ustment ................ ......................................................................................... 1
20 178766 HANDLE • Pulley Adj ustment ........... .............. .................... ..................................... .. .................... . 1
21 014170 BOLT · Carriage ....................................................................................................... ....................... 2
22 178763 SPACER - Pulley Handle ..................................................................... ................. ....................... 2
23 150083 NUT - Lock, 10-32 ............ .................... ..... ......................... .......................... ................................... 4
24 178738 SHAFT - Conveyor Drive ....................... ...... ................................................. ............ .. ..................... 1
25 150085 NUT- 1/4-28 ...................... .... ........... ..... .................... ...... ..... .... .... ............................ ........ .............. . 4
26 186414 RETAINER - Bearing!, nos ............................... .......................... ............................... .. ..................... 1
27 021861 WASHER - .196 i.d. x .437 o.d .......................... .............................................................................. 2
28 000666 WASHER - .200 i.d. x .334 o.d ... ....................... ............................................... ............................... 2
29 102345 SCREW· 10-32 x 1/2 " .................................................................................................... ................ 2
30 172239 BRACKET - Conveyor Support ...... ........... ....................................................... .......... ..... ................ 2
31 100653 SCREW· 1/4-28 X 3/4" ...... ..... ........... .... ......... ................ .... .......... ................................................... 8
32 178764 RAIL- Top Plate ..... ............................................................................ ............... .............................. 2
33 101483 SCREW - Cap ........ ........... .............. ........... ..... .................................................. .............................. 4

UNIVERSAL FEEDER
5 ~-- 13
7 - - - - - - --
6----~
8 - - - - - -..F
9,, 10 -----/ ,,
,,....., 12
"-,
11 ________, ',,"-,
',, 18
"-,
19 -------------~~
'',
27
20 ---------------------~
21-------------------~ 28
22 ------------------~
16 - - - - - - -
1 5 - - - - - - -,
24 --------'
25 ------------.J

UNIVERSAL FEEDER
BAIL BAR ASSEMBLY
Index Part
1 172968 LABEL· Scale ................................................................................................................................ 1

2 178920 STUD -Threaded .......... ......... ............... ..... ..... .............................. .................... .............................. 1
3 178917 MOUNTING BRACKET ASSEMBLY ... ................................................... .................. ....................... 1
4 178921 BAR - Paper Hold Down .. .............................................................................................................. 1
5 065361 SCREW - Thumb ....................................................................................... .................................... 2
6 178927 MOUNTING BRACKET - os ..... .................................................. ...................................................... 1
7 102350 SCREW - 10-32 x 3/4" ...................................... .......................................... .................... ................ 1
8 100740 RING - Retaining ............................................ ..................... ......................... ............ .. ..................... 1
9 102351 SCREW - 5/16-24 X 3/4" ... ............... ............... .......................................................... .. ..................... 2
10 180444 BUMPER ........................................................ .. ............. .............. ................ .............. .................... . 2
11 100710 NUT- Hex, 5/16-18 ......................................................................................................................... 4
12 180443 BRACKET - Bumper ....................................... ..... ................ .... ..................... .............. ..................... 2
13 172240 PIVOT· Conveyor ............. ..... ......................... ...... ..................... ................... ................................... 2
14 190254 NUT- Hex ........... ............................................................................................................................. 2
15 180537 SHAFT - Control ................................................... ............... .............................. ............... ............... 1
16 100554 PIN - Spiral ......... .............. ..... ......................... ........................................ ................. ........... ............ 1
17 180472 KNOB .............................................................. ................................................................................ 1
18 180538 BRACKET- Support ........ .................... ........... .. ................. .................... ......................................... 1
19 193577 WASHER- Spring ............. .... ............... ................................... ................................ ....................... 1
20 180531 WASHER · Friction ............ .............. ..................... .......... ..... ......... ............................ .. .................... . 2
21 003586 WASHER- .380 i.d. x .750 o.d ........................................................................................................ 2
22 150088 NUT - Lock, 3/8-16 .......................................................................................................................... 2
23 102386 SCREW - 10-32 x 1/2" ................................... ...... .............................. ............................................. 1
24 180530 STUD -Threaded ............................................................................................................................ 1
25 180539 LEVER ASSEMBLY- Regulator ....... ..... ................ .... ..... ...... ..... .... .......... ................ ........................ 1
26 180534 NUT- Special .... ................ .............. ........... ..... ...... ....................................... ............ ....................... 1
27 014459 RING - Bowed "E" .............. ............................. ..... ........... ..... ..................................... .. ...... ............... 1
28 001060 RING - Retaining ................................................................................ ........................ ..................... 1

UNIVERSAL FEEDER
1
'------6
. - - - - - - - - -·- - - --- - - - - - --- - - - ---- - - - - - - -

- - - - - -17
14
23 - - -
r-13
22---
21------ F~'---___,......-.../

UNIVERSAL FEEDER
BRUSH ASSEMBLIES
Index Part
1 172120 BRUSH ASSEMBLY- (NOS) ........ ............... ......... ...................................................... .................... 1

2 179232 CLAMP .............................................. ............................................................................................... 1
3 015118 WASHER- Spring .................................................................... ......................... .... ... ....................... 2
4 014713 WASHER- .203 i.d. x .750 o.d ... ........................................................................... ......... ................. 1
5 150083 NUT - Lock, 10-32 .......................................................................................................................... 1
6 014464 RING - Grip ................................................... ........................... ....................................................... 1
7 172266 SCREW - Knurled ............. .............................................................................................................. 1
8 065361 SCREW - Thumb ............................................................................................. ....... .. ..................... 1
10 172117 BRACKET ASSEMBLY- (NOS) ....................................................................................................... 1
11 180662 BRUSH - Trail Edge ........................................................................................................................ 1
12 172114 SPRING - Torsion ................................................................... ............................... ......................... 1
13 172216 BRUSH ASSEMBLY - (OS) .............................................................................................................. 1
14 150083 NUT - Lock, 10-32 .............................................................................. ............................................. 1
15 014713 WASHER - .203 i.d. x .750 o.d ........ ................................................................................................ 1
16 179232 CLAMP .......................................................................................... .................................................. 1
17 014464 RING -Grip ..................................................... ..................................................... ........................... 1
18 172266 SCREW - Knurled ............. .............................................................................................................. 1
19 172269 SPRING - Torsion ............. .............................................................................................................. 1
20 180662 BRUSH - Trail Edge ......... .............................................................................................................. . 1
21 172215 BRACKET ASSEMBLY- (OS) ........................... ................................ ....................... .. ..................... 1
23 065361 SCREW - Thumb .............. ........................................................... .................... ....... .. ..................... 1

UNIVERSAL FEEDER
,r----5
_,---6
~-7
NOS

UNIVERSAL FEEDER
LOWER FEED ROLLER AND GEAR ASSEMBLY
Index Part
1 080312 BEARING ......................... ..... ........... .... ......................................... ......................... .......... ................ 3
2 172149 SHAFT - Doubles Diverter ............ .... .......... .............................. ...................................................... 1
3 080312 BEARING ............... .......................... .... .......... ............................... ......................... .......................... 2
4 172131 HUB - Bearing Retainer ... ..... .......... .............. ............................................... ................... ................ 3
5 197145 WASHER · Wave Spring .......................... .................................................. .................................... 3
6 191384 WASHER · .260 i.d. x .750 o.d .............. ......... .... ........... ..... ......... ................................... ................. 1
7 100339 SCREW · Cap, 1/4-28 x 3/8" .................... ................ ......... ............................................................. 1
8 172133 PLATE - Bearing Retainer ............... ..... .... ................. ..... .................... .......... ................... ................ 1
9 102129 SCREW . 10· 32 X 7/8" ................................... ... ... ..... ..... .... ..... ........... ............................................. 6
10 102345 SCREW- 10-32 X 1/2" ......................................... ........................................................................... 6
11 000666 WASHER - Lock ................ .............. ..... ..................... ..... .............................. ..... ............................. 12
12 173132 PLATE - Bearing Retainer .................... ............................... ......................... ................... ................ 2
13 178723 SHAFT - Cam .... .................... ..................... .... ...... ........................................................................... 1
14 172139 BLOCK - Guide Support ... .................................... ..... ..... ...... ......................... .... .............................. 2
15 192125 WASHER ............ .............. ............................................................. .......... ..... .... ............... ................ 4
16 014175 SCREW. 10-32 X 7/8" ......................... ................................................................. .......................... 4
17 172145 ROLLER AND GEAR ASSEMBLY- Lower Feed .... ..... ...................... ............................................ . 1

UNIVERSAL FEEDER
~- 2
1

UNIVERSAL FEEDER
CONVEYOR HOLD DOWN ROLLER
Index Part
1 196849 SCREW - Shoulder Pressure Roller ......... ..... ..... .................................................... ....................... 1
2 179232 CLAMP · Pressure Roller ................. ..... ..... ......... ................ ..... ......... ......................... .................... 1
3 179234 STOP - Roller Arm ........................... ............... ................................................................................. 1
4 014713 WASHER- .203 i.d. x .750 o.d........ ...... ......... ................................................................................. 1
5 150083 NUT - lock, 10-32 ........................................... ............ .................................. ..... ....... ........ ............... 1
6 172266 SCREW - Knurled ............. .............. .............. ................. ................................................................. 1
7 172111 ARM- Roller ........................................................ ..... ...................................................................... 1
8 197000 BEARING - Paper Hold Down .......... ......................... ...... ..... ............................. ............... ............... 1
9 150083 NUT - Lock, 10-32 ................................ ......... ..... ...... ..... .... ............................................. ................ 1
10 014713 WASHER- .203 i.d. x .750 o.d ....................... .................... ......................... ................... ................. 1

UNIVERSAL FEEDER
~-·-6

UNIVERSAL FEEDER
SHEET SEPARATOR AND BLOWER
Index Part
1 102390 SCREW • 6-32 X 5/16" ..................................................................................................................... 4

2 178965 SPRING .......................................................................................................................................... 4
3 172230 STOP ............................................................................................................................................... 4
4 172617 BODY - Blower ............................................................................................................................... 2
5 101031 SCREW - 6-32 X 3/4 .................................................. .......... .............................. .............................. 4
6 065361 SCREW - Thumb ...................................................................................................... ..................... 4

UNIVERSAL FEEDER
r - - - -10
4 11
12
2---..
14
3 6 - --
~· 30
~"'--
29
33-----'
34
24

UNIVERSAL FEEDER
BAIL BAR SOLENOID I LEVER ASSEMBLY
Index Part
1 178907 BRACKET - Solenoid ...... ................ ..... ......... ................................ .................................................. 1

2 102386 SCREW- 1/4·28 X 1/2" ..... ................ .... ............... .......... .............. ...... .......... .... ............................... 2
3 102370 SCREW- 8-32 X 1/4" ........................ .... ..................... ············································ ... ....................... 2
4 102380 SCREW - 10-32 X 3/8" ····· ······ ·········· ···· ···· ...... ... .......................................... ............. ······················· 1
5 250203 CLAMP - Cable .................................................................................. .............................. ............... 1
6 178906 STUD- Pivot ..................... ................... ........................... ................................................................ 1
7 197175 STUD -Spring ................................................................................................................................. 1
8 193035 SPRING ...................................................... .......................... .............. ................ ............................. 1
9 178903 STUD - Pivot ........................... ......... ..................... .................... ....................................................... 1
10 178901 LEVER ASSEMBLY- Cam Follower ............................................................................................... 1
11 197001 TRACK - Roller ................................. ............................... ..... ............................ ............................... 1
12 150084 NUT- Lock, 1/4-20 ............................................................. ......................... ................................... 1
13 001080 RING - Retaining ................... ............................... ........................................................................... 1
14 192182 SPRING - Extension .......... ......................... .... ...... ................ .......................................................... . 1
15 178904 LEVERASSEMBLY ..................................................................... ................ ............ .. ..... ................ 1
16 001060 RING - Retaining ............................................ .................................... ............................................. 1
17 197166 SPRING - Extension .......... ................................................... ............................. ............................. . 1
18 073325 SPRING ...................................................... .......... ................ .............. ................ ............................. 1
19 101626 SCREW - Cap, 1/4-20 x 5/8" .............................................................. ............................................. 1
20 172898 BRACKET - Bail Bar Connector ...................................................................................................... 1
21 173461 LEVEL ASSEMBLY - Height Control .............. .. .................. ............................................................ 1
22 180532 LEV EL ASSEMBLY- Optical Switch ................ ...... .......... ........................ ......................... ............... 1
23 016289 SPRING- Lever, Right Hand ................................ ......................................................................... . 1
24 172995 HARNESS - Feeder Interconnect ; With Table Height Sensor ....................... ............... ................ 1
25 102385 SCREW - 4-40 x 5/16" .............................. ............................... ................ ........................................ 2
26 014515 RING- Plastic .................................................................................................................. ............... . 2
27 190713 PIN .................... ................................................................................ ................ .... .. .. ..................... 1
28 253375 SOLENOID ...................................... .... ..... ...... ..... ................................... ......... ........ .. ..................... 1
29 178908 BRACKET HOUSINGASSEMBLY ...... .... .... ....... ..... ........... ......... ............................... ..................... 1
30 102345 SCREW- 10-32 x 1/2" ...................................... ................................. ............................................. 3
31 180987 BRACKET - Switch Mounting ......................... ..................... ............... ...................... .. ..................... 1
32 190731 PLATE - Nut ........ ............... ................... ...... ..... ..... ..................... .................................. ................... . 1
33 253822 SWITCH .............................................................................................. ............................................. 1
34 102373 SCREW - 6-32 x 7/8 ................................................................................................... ..................... 2
35 172997 HARNESS - Bail Bar Solenoid ........ .... ........... ........................ ................ .... ................................... . 1
36 172996 HARNESS - Feed Table Limit Switch ...... ........................................................................ ............... 1

UNIVERSAL FEEDER
7, 8
- - 11
4
~13
/\12
~n
. '
I o
! I
' :
~--17
' - - - 14

UNIVERSAL FEEDER
DOUBLES SENSOR
Index Part
1 187264 TRAY · Paper .................................................................................................................................. 1

2 102336 SCREW · 4·40 x 5/16" ..................................................................................................................... 4
3 100115 NUT ................................................................................................................................................ 4
4 102345 SCREW- 10-32 X 1/2" ................................................................................................................... 13
5 021861 WASHER - .196 i.d. x .437 o.d ...................................... .................................................................. 2
6 186405 FILLER - Diverter Gap .......................... .............................. ............................................................. 1
7 172919 BRACKET- OS .......... ............................................ ............... .............................. .............. ............... . 1
8 172920 BRACKET - nos ................................ .... ......... .................................................... ....... ....................... 1
9 003855 WASHER - .256 i.d. x .500 o.d ................................................ ........................................................ 4
10 101626 SCREW- 1/4-28 x 5/8" .................................................................................................................... 4
11 197087 PLATE - Pivot, os ............................ ................ .. ......................................................... .... ................. 1
12 014326 SCREW. 10-32 X 7/8" ......................... ......................................... ........................... .. ..................... 2
13 021861 WASHER- .196 i.d. x .437 o.d .................................................... .................................................... 4
14 172119 GUI DE- Lower Feeder Paper ......................... ................................................................................ 1
15 001804 NUT· 10-32 ................................................ .... ............................................... .................................. 1
16 250356 CLAMP- Cable ........................................................................................................... .................... 1
17 172146 SENSORASSEMBLY ....................... .... .......................................................................................... 1
18 021861 WASHER - .196 i.d. x 437 o.d ................ .................... ............................................... ....................... 2
19 172147 IR EMITTER ASSEMBLY ...... ............................................................. ........................ ...... ............... 1
20 172135 BRACKET -lA Emitter Assembly ................... .................................................. .............................. 1
21 079764 CLAMP - Cable, Plastic ................ .... ..................... .... ............................................... .... .... ............... 3
22 172367 CLIP ·Spring .......................... .............. ...... ..... ................................................................................ 2

UNIVERSAL FEEDER
1 2 32,332
10 r
J
26, 27' 28, 2~
0
-T
10, 11
34, 35, 36 12
3
13
14
15
7
16
6 31
19
4
5 20 17
21 18
Section A-A

UNIVERSAL FEEDER
FEED TABLE ASSEMBLY
Index Part
No. No. Desc ription Quantity
1 180628 PLATE ASSEMBLY - nos ............... ...... ....................................... ..... .......... ................................... .. 1
2 180598 TABLE FEED .. ......... .................... ..... ............... ................................................. ............... .. ............. 1
3 180627 PLATE ASSEMBLy - OS 00000 00 00 00 000 00000 00 000 00000 0000 . . . . 1
00 0000 000000 0000 00000 0000 0 0 0 0 0 0 0 0 0 0 0 . . . . . 0 0 0 0 . . . . . 0 0 0 0 0 0 0 0 . . . . . . . . . . .. . . . . . . .
4 180609 SLEEVE .................. ........... .... ..... ...... .... ......... ................................ ......................... ... ..................... 1
5 100653 SCREW - Cap, 1/4-28 x 3/4" ............................................ ................................... ........................... 4
6 001842 NUT - 3/8-16 ...... .............................. ..... ........ ...... .......... .... .............................................................. 4
7 180611 CONNECTOR - Chain ...................................................................................................... ............. 2
8 180708 CHAIN ASSEMBLY - nos ................. ......... ..... .... ............... ................ .............................. ................ 1
9 180640 CHAIN ASSEMBLY - os ................................. .......... ................ ....................................................... 1
10 003578 NUT- Hex, 1/4-20 ......................................... .................................................................................. 2
11 197421 PLUNGER - Spring ............................. ..... ...... .............................. ..... ............................................. 2
12 014788 WASHER- .260 i.d. x .625 o.d ......... .... ......................................... .......................... .. ...................... 8
13 191797 WASHER - .265 i.d. x .625 o.d ......... .... ......................................... .................................................. 8
14 014162 SCREW - 1/4-28 X 1/2" ................... .... .......................... .... ..... 8 0000 00 00 000 0000000000000000000000 000000 0 00 00 0000 00 000 00 00
15 101086 SCREW - Cap, 1/4-28 x 3/4" .............. ................ .............. ................... ........................................... 4
16 180624 BAR - Feed Table Cross .................................... .............................. .............. ................ ................ 1
17 100622 SCREW - 1/4-28 X 5/ 8" 00 00 00 00000000 00 00000000 00 00 0000 00 00 . . . 00000000 00 00 00 00 000 0000 00 4 00 00 00000 . . . . . . . . . . . . . . . 000 00 00 00 00 000000000000 0000
18 180607 RETAINER ........................................................... ......... ........... .... ..... ...................... .. ...................... 4

19 180606 STUD- Table Truck ....................................... .................................................. ............................... 4
20 102493 "E" RING ................. .......................................................... .............................................................. 4
21 186628 WASHER - .507" i.d. x 1.000" o.d. ................ .................... .............................. ........ .. ...... ................ 4
22 197222 BEARING - Needle ............................. ........... ..... .... ................ ..... ......... .............................. 4 00 . . . . . . . . . .
23 014788 WASHER- .265" i.d. x .625" o.d. 2

o o o o o o o o o o o o o o . . . . . . . . . o o o o . . . . . . oo . . . . . . . . . . . . . . . . . . oo . . oo . . . . . . . . . . . . . . 0 0 . . . . . . . . 0 0 . . 0 0 . . . . . . . . 0 0
24 101626 SCREW - 1/4-28 X 5/ 8" 00 0 . . . . . . . . . . . 00 000 00 00 . . . . . . . . . . 2

. . . . . . 00000 00 000 . . . . 00 000 . . . . . . 00 000 0000 . . . . . 0000 . . . . . . . . . . . 00 . . . .. .. .... .. ... .. . 0
25 180615 BRACKET - Chain Connector .......................................... .................... ......... ...... ........................... 2

26 173197 BRACKET- Conveyor ............................... o o o o · oo . 2
. . 0 0 0 0 0 0 0 0 0 0 0 . . . . 0 0 0 0 0 0 0 0 0 . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 o o o o · 0 0 0 . . oo . . . 0000 00 00 00 00 . . . . .
27 001731 WASHER -Lock, .250 i.d. x .485 o.d. 4

0 0 0 0 0 0 oo . . . . . . . . . o o o o o o o o o o o o o o o o o o o o o o o o . . . . . . . . oo . . o o o o o o • • oo o o o o o o o o o o . . . . . . . . oo o o o . . . . o o .
28 101626 SCREW - 1/4-28 x 5/ 8" .......... 4

o o o o o o o o o o o o o o oo oo oo . . . . . . . . . . . oo . . o o o o oo . . . . . . . . o o o o . . . . . . . . . . oo . . . . oo . . . . . . . . . . . . . . . . . . . . . . oo . . . . . . .oo.
29 191384 WASHER - .260 i.d. x .750 o.d. o o o o . . . . . oo . oo o o o o . 4

. . oo . . . . . oo oo oo . . . . . . . . oo • • oo . oo . . . . . . oo . . o o o o oo oo • • • oo . . . . . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . .. . . . . . 0 0
30 072036 CONNECTOR - Table 2

o o o o o o o o o o o o o o o o o oo o o o o o o o o o . .. . . . oo . . . . . . o o . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . . . . . . . 0 0 0 0 0 0 0 0 0 . . . . . . . . 0 0 . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0
31 020379 SPRING .. oo. . . . . . . . . . . . . . . 2

. . oo . . . . . . . . . . . . . . . . . . . . . . . . . . . oo . . . . . . . . oo . . . . . . . . . . . . . oo . . . oo . . . . . . . . . . . oo . . o o o o . . . oo . . . . . oo . . . . . . . oo . . . o o . . . . .. . . . . .
32 173663 ARM - Support, nos ....... oo 0 0 0 0 0 0 0 0 0 0 . . . 0 0 . . 0 0 0 0 0 0 0 0 oo . . . . . . . 00 0000 . 1

. . oo oo • • • 0 0 0 0 0 0 0 0 0 0 oo . . . oo . . . . . 0 0 . . . . . o o o o . o o o o o o o o . . . . . . . . oo . .. . oo . . .
33 173662 ARM - Support, os 00 0 1

0 0 0 0 0 0 0 0 oo . . . 0 0 0 0 0 0 . . oo . . . o o . 0 0 0 0 . . . . oo . . . . 0 0 0 0 0 . . o o . 0 0 0 0 oo o o · 0 0 0 0 0 . oo . . . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . . . 0 0 0 0 0 0 . . . . . . . o o . . . 0 0 . . . 00 00
34 094449 BOARD- Paper Support, 8-1/2" x 11 " .... 1

oo . . . . . . . . . . oo . . . . . . oo oo • • oo . . . . oo . . . . o o . o o o o o o o o o o . . . . . oo . . . . oo oo oo . . . . . . . .. . . . o o . . oo oo
35 094428 BOARD - Paper Support, 11" x 17" 0 0 0 0 0 0 0 0 0 0 oo . . . . . . . 1

o o o o oo o o oo . . . . . . . . . oo . . oo o o o o o o o o o . . . . oo . . . . . . . . . . oo . . . . oo . . oo . . . . . .. .. . . . . . .
36 180849 BOARD- Paper Support, 13-1/2" x 17" .. 1

oo . . . . . . . . . . . . oo oo o o o o o o . . . . . . . . o o o o . . . . . . . . o o o o . . . . oo . . oo o o o o o o o o o o o o o o o o o o o o o o o o o o o o oo

STREAM FEEDER

,..
(b
,..
0
a: , . ~~
~:.,
~
,, ,,,
0>
0
w ',. ...
l
\ ~ ~
m
J!;....:"'..:"'J, ~
c \~'\ - ,.
,,,,..._..,,.
\\ v \. .r \
.-'
,. I
\
~
~ ~
~ ~
~
(.)
w '\.,.---
j
- "" . \ , ••
"
\ I"\
I
\
I
~ ~
~ ~
(/)
t::
w ,,.,~
\'' \
' \ \
\
\\
\\
I\ \
\ ~
;;,\
.. \
~ ~
~ ~
~ ~
co
ll..
LL ,.. '\"
' <; \•\\ r' \ \
\
\ ~ ~ 0
~ ~
,.. 'c-=.--=.~ ,,.n ' ''\' \ \ \ \ ~ ~
~ ~
0
1.0
~ \\ \\_\
~ \
~ ~
~ ~
C")
<
w ~---
' ~ ~
\\ \-'
~ ( ' •'
\ \
\
~ ~
~ ~
~ ~
~ ~ -~
:::l
c
~.,.;:'...:::-"...:''\1'1 - - ' \ ' \
a:
~
''"'
\ '....
\ \
,,,,
v
,~- - ./ ,, ,,
,- - ""' \'' \ .. ~ ,,,, \
\
~ ~
~ ~
~ ~
~ ~
(])
(.)
en . , ,. , ~ ~
\
~ ~
\\,, •• \.J \ ~ ~
~,,, ~ ~
,~, "" p~, ... ,\ ~ ~
\V
\ y·
\•1
"' ~~
~ ~
II \ _. \
~ ~
' ,, \ \ ''
,, r
.I ''
,.,.., ~ ~
\\\',, ''\\ ,r~" '\ ~ ~
Cl'\~\ ~ ~
,,, ,,'\ (!''' ~ ~
~ ~
\ \
\ ,.,. \' ,... ? \ \\ \ ~ ~
\ \\
\ ... __
,·---- ,,,\ \ \\\ ',
.....)...,.
\
\'
\
,,,.,
~ ~
~
\ \
----~ \
..._.,,
\ \. \
...\ .:,\ \ \
\
'\ \ ·~
/
~
\\
,, /,..../
I
\ \ \ ~o ,
,..co '\ \
\\ \I
'·
en
,.. f. '\ ,,
'f"...I".J ..,, ~
\
\ ~·
... "\\ II)
,.. ~~ .....~
.' .~& ~ ,~7
~.
\ GJ
. ~,
.J ;,>:
'.11- - - I {I
~
,.. "" \ p'
,.. ,.. \ ~I :A"e
.t ' ' ,~tt .1 .II I
~I ,.. y .,~ . ~
e ' '
~'
--'({' 11
I \~ \ I''\... ,
'- 0
1>~ A~
\'V..... ""' N
N
~ ~
•,·-.!'---........
"
'I"'
,~,
II
I \ ,·-.._ ,
I I
(
A
··'
~~
I \ . \
I ~ \ ..... • ; ., \
,
~ ~ \ .'
,, 'J
.· ...J.'
·. \ t
C\J
r --wr-~v}
I
t'- ,....., \ f'-..
en
,.. ,.. ,..CD
STREAM FEEDER
OPERATOR SIDE COVERS- PART 1
Index Part
1 102165 SCREW - Phillips, 10-12 x 1-1/4" ................................................................................................... 8

2 101144 NUT - Self Clinching ....................... .................. .. ...... ..................................................................... 8
3 014295 SCREW - Phillips, 6··3 2 x 3/8" ......... ..................................................................... .................... ...... 8
4 173127 NUT - Self Clinching ....................... ................................................................................................ 8
5 001649 SCREW · Phillips, 10-32 x 1/2" ...... ........... .... ........... .......... ..... .................... ................................... 6
6 172908 BEZEL · Plastic Frame ......................................... ......... ...... ..... ..... ............... .................................. 4
7 188220 PANEL - Fixed, Tower 1 and 2 ....................................................................................................... 2
8 101743 SCREW - Phillips, Tower Insert ...... ..... .......... .. .. ...... ..... ..... ..................................... .. ..................... 8
9 188441 COVER · Fdr. (O.S. Stream) ................................ ..... ..... ..... ...... ...................................................... 1
10 188443 PANEL - Fdr. Inset (O.S. Stream) ......................... ................... ........................................................ 1
11 188447 COVER · Tower 1 (O.S.) .................. ........... .... ........... ...... .... ............................................................ 1
12 188449 COVER· Mid (O.S.) ......................................... .............. .............................. ................................... 1
13 188451 COVER · Tower 2 (O.S.) ....................................... ........................................................................... 1
14 188455 COVER · Filler Delivery ......................................... .... .......... ............................................................ 1
15 174188 DECAL · Pull Guide Vacuum ........................... .. ........... ..... ......... ................ ............ .. ..................... 1
16 187084 DECAL · Ink Control ........................ ............................... .... .......... ................................................... 2
17 102157 SCREW· Button, 10--32 x 1/2" .............................. .......... ..... ............................................................ 2
18 174194 DECAL - Back Jogger Adjustment ... ................ ... ..... ......... ...... .......... ............................................. 1
19 174197 DECAL - Fountain Sweep ............................................................................................................... 2
20 174196 DECAL • Quick Raise ............................................... ........... ........................................................... 1
21 174199 DECAL · Lateral Paper Adjustment .... ..................... ..... .... ................ ...................... ....................... 1
22 400757 DECAL- A.B.DICK ........................... ...... ..... ..... ..... ................ ..... .... .......... ........................................ 1
23 174193 DECAL · Lateral Adjustment .......................................................................................................... 2
24 403400 U.S. Flag ........................................................... .......... ..... ...... ..... ......... ............................................. 1
25 187728 BEZEL - Long, Control Panel ........................................................................................................... 1

STREAM FEEDER

STREAM FEEDER
OPERATOR SIDE COVERS - PART 2
Index Part
1 102157 SCREW · 10-32 ............................... ................................................................................................ 2

2 173081 BRACKET - Lower Cover Mount ..... .... ..... ..... .............................. ............... .................................... 7
3 186764 PANEL - Inside Delivery, os .. .......... ..... .............................................. ...................... ....................... 1
4 014183 SCREW- Hex Head, 5/ 16-18 x 5/8" ......................................................................... ....................... 2
5 187722 RAIL- Upper Cover ............................... ..... .... ...... ................ ........................ ................................... 1
6 188445 COVER - Lower Feeder, O.S. Stream ... ..... .... .. .. ..... ................ ............... .......... ....... ....... ................ 1
7 188453 COVER -Lower Delivery, (O.S.) ........... ...... .... ...... .......... .......................................... ...................... . 1
8 102165 SCREW- Phillips, 10-12 x 1-1/4" ............... ..... .... ............... ..................................... .. ..................... 7
9 193338 WASHER- .257" I. D. x .120" thick ... ..... .......................... ................... ...... ..... ............ .. ..................... 2
10 001667 SCREW - Hexagon, 1/4-20 x 5/8" ......... ......... ................. ......................... ..... ......... .......................... 5
11 021013 SCREW - Hexagon, 1/4-28 x 5/8" ......... ............................... ......................... ............ ....................... 1
12 174185 DECAL - Fork Entry ...................... .... ............... ...... .... ......................... ..... ..... ..... ............... ............... 2
13 173083 GASKET- Foam Rail .............. ......... .......... ..... .......... ................ ..... .... ..... ..... ........... .... .................... 2
14 187475 LOWER RAIL ........................................ ............ .. ............................... ......... ..... ........... .................... 1
15 173079 BRACKET - Mounting (Skirt Delivery) ... ...... ..... ..... .... .......... .......... .................... ....... ....................... 1
16 173150 INSULATOR- Foam Delivery Cushion ................................................................... ....................... 1
17 188251 LABEL - Stripe, P34 (Str. Fdr.) ........................................................................................................ 1
18 188250 LABEL -Logo, P34 (Del.) ............... ................................................................................................ 1
19 102124 SCREW -Void, Cap Button Head ... ............................................................................................... 2
20 014209 SCREW · Hex Head, 5/16·24 x 5/8" ..... .... ...................... .... ..................... .............. ... .. .................... . 2
21 173075 PANEL - Inside Delivery .................. ...... ..... .... ...... .............. ..................... ..... .... ........ .. ..................... 1
22 150083 NUT - Lock, 10-32 ............................ ....................................................... ..... .... ..... ... ....................... 4
23 102157 SCREW- Button Head, 10-32 x 3/8" .............. .. ... ......... ................ .......... ......... ...... ..... ................... . 4
24 014353 SCREW- Hex Head, 1/4-28 x 1/2" ........ ........... .. ................ .................... ..... .... ........ .. ..................... 1
25 001812 NUT- Hex ........... ............... ........... .... .... .......................... ................ .... ..... ........... .... ......................... 2

STREAM FEEDER

STREAM FEEDER
NON-OPERATOR SIDE COVERS- PART 1
Index Part
1 188452 COVER · Tower 2 (N.O.S.) ............. ................................................................................................. 1

2 188450 COVER· Mid (N.O.S.) ..................................................................................................................... 1
3 188448 COVER- Tower 1 (N.O.S.) ........................................................................................................ ...... 1
4 188444 COVER ASSEMBLY - Feeder Inset ( N.O.S. Stream) .................................................................... 1
5 188442 COVER - Fdr. (N.O.S. Stream) ................... ....................................................... .............................. 1
6 174192 DECAL · Master Power ...... ............................. ................................................................................ 1
7 102165 SCREW- Phillips, 10-12 x 1-1/4" .................................................................................................. 16
8 014209 SCREW - Hex, 5/16-24 x 5/8" ..................... ............................................................. .. ..................... 2
9 014183 SCREW - Head, 5/16-18 x 5/8" ........ ............................................................................................... 2
10 187725 RAIL - Upper Cover ......................................................................................................................... 1
11 101144 NUT - Self Clinching ........ ............... .... ........................................................................................... 10
12 102157 SCREW · Button, 10··32 x 3/8" ............................................. ..................................... .. ..................... 4
13 173078 BRACKET - Magnet ....................................... .............................. ................................................... 1
14 101548 CATCH- Magnetic ........................................................................................................................... 1
15 150083 NUT - Lock, 10-32 ................................ ......... ..... ...... ...................................................................... 2
16 001649 SCREW- Phillips, 10-32 x 1/2" ....................................................................................... ................ 3
17 188455 COVER · Filler Delivery ..................................................................... ............... .............. ............... . 1
18 174185 DECAL - Ink Roller Clean up .......... ................. ...................... .......................... ....... .. ..................... 2
19 174198 DECAL · Night Latch ...................................................................................................................... . 2

STREAM FEEDER

STREAM FEEDER
NON-OPERATOR SIDE COVERS· PART 2
Index Part
1 150083 NUT· Lock, 10· 32 ....................................................................................... ................................... 8

2 188456 DOOR ASSEMBLY· O ill Pump ........ ............................................. ............................ ....................... 1
3 173506 DOOR - Stop ......................... ............... ......... ................................................................................. 1
4 197195 WASHER · .257 i.d x .500 o.d.......... ..... ......... ... ............. ..... .... ..... ...... ............................................. 1
5 102157 SCREW- Button, 10-32 x 3/8" .............. .......... ............... ..... ......... ................................................... 7
6 001677 SCREW - 1/4-28 x 5/8" (for lower rail) .................. .... ..... ...... ..... ...................................................... 5
7 021013 SCREW - Hex, 1/4-28 x 5/8" ............ ................. .. ..... ...... ..... .... ....................................................... . 1
8 111056 SCREW- Hex, 10-32 x 5/8" ............. ......................... ..... ..... ............... ...................... ....................... 1
9 173080 SKIRT- Delivery .............................................................. .................................. .............................. 1
10 174185 DECAL- Fork Entry .. .................... .... ............... ...... .... ..... .............................. ................................... 2
11 173150 CUSHION (Insulator, Foam Delivery) ........ ............... .......... ............... ...................... ....................... 1
12 188454 COVER - Lower Delivery (N.O.S.) .............. .......... .......... ..... ..... ....................................................... 1
13 102303 SCREW - Hex, 1/4-20 x 3/4" .. .......... ...... ........ ........... ...... ..... .... ..................... .................................. . 2
14 150084 NUT - Lock, 1/4-20 ......................................................... ..... ............... .......... ................................... 2
15 188446 COVER- Lower Feeder (N.O.S. Sir.) ... ............................... ..................................... .. ..................... 1
16 173077 BRACKET - Oil Panel ........ ................... ................ .... ..... ........... ......... .......... ................................... 1
17 187742 RAIL- Lower ..................... ............... ........... ..... ...... .... ..... ...... .... ..... .... .. ......... ............ .... .... ............... 1
18 193338 WASHER- .257 i.d. ......................... ..... .......... ................ ................................................................. 1
19 173083 GASKET - Foam Rail ....................... ..................... .... ................ ................... ............ ....................... 2
20 014353 SCREW - Hex, 1/4-28 x 1/2" ............ .............. ................. ..... .... ......................... ............................... 1
21 173075 PANEL· Inside Delivery .................. ............... ................ .... ..... ..................... ............ .. ..................... 1

STREAM FEEDER
- - -- 4

STREAM FEEDER
SHEET SEPARATION UNIT- PART 1
Index Part
1 102512 SCREW - Hex, Zinc, 5/16-18 x 1 3/4" .......... ...... ......................... .... ......................... ....................... 4
2 187615 TIEBAR - Head, Upper Unit ............ ..... ........................................................................................... 2
3 180780 ELBOW- 90 Degree x 3/8" ... ............... ......... ..... ............... ..... ..... ............................ ........................ 1
4 197306 TUBE - Sucker Vacuum .. ..... .......... ..... ......... .................... ........................ ...................................... 1
5 001523 SETSCREW - Zinc, 1/4-28 x 5/16" .... .................... ..... .......... .................................. ........................ 1
6 102527 SCREW - Shoulder, 1/4-20 x 3/8" ................ ..... ............................................................................. 2
7 102040 SCREW- SHCS- 1/4-20 X 1/4" ........................................ .............................................. ................ 2
8 187612 FRAME - Head Manifold, os .............. ...... ..... ......... ..... ..... ...... ............................. .............. .............. 1
9 187605 PNEUMATICVALVE&SOLENOIDASSY. ............ ...... ........... .............................. ........................... 1
10 101395 0-RING - Rubber .... ........................................................ ...... ......................................................... 1

STREAM FEEDER
.....___- - -11
~--- 12

STREAM FEEDER
Index Part
1 18751 1 DRIVESHAFT - U-Joint ... ............... ..... ............. .. ........................ ................ ..................................... 1
2 102457 BEARING- Ball ............... .................... ........................................... ......................................... ....... 1
3 187607 CAM - Separator Foot Lever .............. ........................................ ................ ...................................... 1
4 187603 SHAFT - Feeder Head Drive .......... .... .............................. ......................... .............. .......... ............. 1
5 186258 CAM - Sucker Drive ....................... .......... .... .... ...... ........... .............. ......................... ....................... 1
6 196873 PIN - Dowel, .2502 I .2500 Hardened Steel ... .. ............................................................................. 2
7 102565 SHIM - Washer, .90 ......................................................................... ............................................... 1
8 187664 PLATE - Rotary Valve Spring .......... ......... ........ ................ ................ .............. ............... .................. 1
9 187609 VALVE - Rotary ............................................. ..... .................... .............. ........................................... 1
10 187612 FRAME - Head Manifold os .......................... .................... .............................................................. 1
11 102457 BEARING- Ball ............... ............................. ... .................. .... ........................ ................ ................. 1
12 014219 CAPSCREW- Black,1/4-20 x 3/4" ................ ..... ............................................................................. 1
13 195837 WASHER -I. D. .275 I .255 .............................................................................................................. 1
14 102515 RING - Retaining, Blk., 1.551 /1.506 ... ..... ........................ .......... ...... .............. ................................. 1
15 102520 SPRING - Compression, C112-L6 ............... .. ... .............. ................ .............................................. 3
16 102441 PIN- Dowel, 1.26/1.24 Sti./Grnd ........ ............. ................. ..... ............... ..... ..................................... 1
17 014195 CAPSCREW- Black1 /4-20 x 5/8" ... ..... ..... .... ... ................. ......... ...... ............................................ ... 4
18 102524 PIN - Spiral, 1.35/1.115 ................. ............... .................................................................................. 2
19 187604 FEEDER DRIVE SHAFT ASSY................................................... .............. ...................................... 1
20 187600 CARDANIC DRIVE ........... ................................................. .............. ............................................... 1
21 187763 BRACKET - U-Joint Guard, Frame....................................... ...... ..... ............................................... 1
22 187765 COVER - U-Joint Guard ...... .................... .............................. ................... ...................................... 1
23 187764 BRACKET - U-Joint Guard Head .. ............... .................................. ................................................ 1
24 187766 SCREW - U-Joint Guard .................................................. .... ........... ............................. .................. 4
25 102418 SCREW - Socket, Black, 1/4-20 x 1/2" ........ .......................................... ........................ .................. 4
26 187767 TUBE - Outer, U-Joint Guard ......................................................................................................... 1
27 187768 TUBE - Inner, U-Joint Guard .......... ................... .............................. ............................................... 1

STREAM FEEDER
'----6
'--7
~8

STREAM FEEDER
Index Part
1 014219 CAPSCREW - Black, 1/4-20 x 314" .............. .... ................. .............. ...... ..... ..................................... 1
2 195837 WASHER - I. D..275 / .255 ............ ..... .......... .................... .......... ...... ............................. .................. 1
3 187516 SPACER - U-Joint Drive ....... ........... .... ......... ............................................. ..................................... . 1
4 102460 RINIG - Retaining, Black ................ ..... ....................................................... .................... ..... ............. 1
5 102457 BEARING - Ball ............................................ .................................................................................. 1
6 187513 HOUSING - Bearing, U-Joint ............. ......... ...... ........................................ ................... ..... ............. 1
7 187604 DRIVESHAFT- U-Joint ................................................................................................................... 1
8 102457 BEARING- Ball ............................................ ... ....... ...... ................................................. .............. ... 1
9 102557 KEY - .75 X .188 X .188 ................................. ........... ..... .................... .... ........................................... 1
10 187514 PULLEY- Drive, Main Drive/U-Joint ............. ..... ............................................................................. 1

STREAM FEEDER
8 - -11
I 1Q---..
16-----~ Bl.--- 12
14---o
1s
I
-----L .T----t---
I
13
I ---.....~ l
I
I I
4
I I
I
I
I
: e -----11 5
~
I
I
6
16 -------~ 15

STREAM FEEDER
Index Part
1 187648 CAP - Sucker Pistons ..... ............... .................... ......................................... ..................................... 2

1A 187644 GASKET - Sucker Caps .. ............... .... ......... ..................................................................... .............. 2
2 187649 PISTON- Sucker ................................. ................................................... ........................ ..... ............. 2
3 197555 SPRING - Compression ... .............. ............... ... ...................... ................ ..... ..................................... 2
4 187658 INSERT - Sucker Bar .............................................. .................... ........................ ............................ 2
5 197538 FITTING-Plug .. ...... ....................... ..... ............... ......... ............... ..................... ................... ............. 2
6 172171 TUBE- Elbow ............................................................................... .................................. ................. 11
7 014195 SCREW- Cap, Black, 1/4-20 x 5/ 8" ........ .... ............................................................. .................. .... 11
8 187654 SKIRT - Suction, White-Lighter Stock .............. ...................... ............................. .......... .................. 2
8 187653 SKIRT- Suction, Pink - Heavy Stock (601b) ................................................................... .................. 2
9 187646.. PISTON - Sucker .............. ................... ..... .... .... ....... ......... ................ .............. ................ ................. 2
10 187657 BAR - Sucker .... ............... .............. ..... ............. ............ ..... .............................................................. 11
11 102521 BUSHING- Flanged, .6280/ .6253 .... ................... ............... ............................................. ................. 2
12 187632* HUB - Separator Foot Lever ........... ..... ..... ..... ... .. ........... ..... ............................ ................................. 11
13 150085 NUT- Lock, 1/4-28 .. ...................... ............................................................ .................... .................. 1
14 187634* HUB - Separator Foot .................................... ... ............ ..... ............................................. .............. ... 11
15 102467 ROL LER -Track Cam, Stud .625 .... ......... ............... .................... .................................. .................. 11
16 102461 BUSHING - .3148/.3125 .......................... ......................... ................ .................................. ............. 2
17 187635 LEVER - Separator Foot ............................................................................................... ..... ............. 11
18 187633' HUB· Cam Follower ........................................................................................................................ 11
* = Use Loctite 680

•• = Use Loctite 242

STREAM FEEDER
~
20
~
2
19 ~ 0
24
23 - - - - - - "
22-----
21 - - - - - . . . - - - - - -10
, . . . - - - - - - - - -11
20----~
- - - - - -12
19----'
~----- 6
' - - - - - - 13
' - - - - - - - - - -14
18 ~,, 15
17
~T"---- 1s

STREAM FEEDER
Index Part
1 102527 SCREW- Shoulder, 114-20 x 318" .................................................................................................. 2

2 014195 CAPSCREW- Black, 114·20 x 518" ............................................................................... .................. 2
3 187620 SHAFT- Sucker, Main ..................................................................................................................... 1
4 187622 LEVER - (nos) Sucker Drive ........................................................................................................... 1
5 005071 WASHER - I. D..254 I .252 .. .......... .......... ........................................................................................ 1
6 102572 CREW · Hex Flange, 114-20 x 1" .................. .... .......... ...... .......... .................................................... 2
7 102525 SPRING- Coil ....... ......... ....................................................... ......................................................... 1
8 187630 SEPARATOR FOOT ASSY................ ............... ...... ..... ......... ..... ......................... ........... .............. .... 1
9 187623 HUB - Torsion Spring .... .................... ..................... .... ................ .................................. .................. 1
10 187626 SPRING - Torsion, Swing Suckers .................................................................... ............................ 1
11 187625 HUB - Torsion Spring .... .................... ..... ......... ....... .... .......... ...... ................................................. ... 1
12 187628 LEVER • Sucker Drive Cam, os .................................. ................................................................... 1
13 102517 CAM FOLLOWER- 318-24 x 718" .................................................................................................... 1
14 187612 FRAME · Head Manifold, os ......... ........... ..... ..... .... ...................................................................... ... 1
15 102493 BEARING- Ball, Ski, 6201·2aRS1 .................. .............................................. ........... ...................... 1
16 014788 WASHER- .265/.255 ................................................ ..... ............................................................... 1
17 014219 CAPSCREW -Black, 1/4-20 x 314" ..... ........... ..... .... ............... ....................................................... ... 1
18 102514 RING - Retaining Bl!<., 1.413/1 .188 ........ .................... .................................................................... 1
19 197118 SLEEVE- Self Lubricating, 1.0. 1/2" ; O.D ..5934 I .5941, L=1/2 .................................................... 1
20 187611 FRAME • Head Manifold, nos ......................................................................................................... 1
21 014909 PIN - Roll - .264 I .258 .................................. .................................................................................. 1
22 187627 RING ·Tension ............................................ ..... ..... .................... .................................................... 1
23 102518 COLLAR - Clamping, 4-40 ............................................................................................................. 1
24 187636 SEPARATOR FOOT ASSY....... ..... .... ..................... ..... ................................................................ .... 1

STREAM FEEDER

STREAM FEEDER
Index Part
1 102511 SCREW- Cap, Blaclk, 1/4-20 x 314" ................................................................................................ 1

2 014788 WASHER ........ ................ ............................................ .............................. ........................ .............. 1
3 102493 BEARING - Ball, SKI , 6201·2RS1 .. ................................................................................................. 1
4 187656 PIN - Diamond, Modified ............... ....................................................... ..... .............. ..... ..... .......... ... 1
5 187617 BAR - Head Clamp ....................... ............... ..................... .... .................................. ....................... 1
6 014219 CAPSCREW- Black, 1/4-20 x 3/4" ..... ......... .... ............................................................. .................. 2
7 187612 FRAME- Head Manifold, (os) ......................................................................................................... 1
8 100891 CAPSCREW- Black, 1/4-20 x 1" ........ .......... ......... ........... .... ........................................ .................. 1
9 197554 TUBING ........... ....... ....... ................ ................... .............................................................................. 1
10 187655 CAM - Sucker Linear ................................... .................................................................................. 1
11 186259 CAM FOLLOWER ... ......... .............. .......... ..... ................................................................ .................. 1
12 150083 LOCKNUT - Flange, 10-32 ........... ............... ... .............................................. ............... .................. 1
13 196873 PIN - Dowel .................................................. .... ......................... ..................................................... 1
14 102519 COLLAR - Clamping ....... .................... .......... .. ................. ......... ..... ............................................. ... 1
15 102522 WASHER- Thrust .......................... .... ............... .............................. ................................................ 2
16 187643 SHAFT- Sucker Pivot ...................................................... ............... ................................................ 1
17 014195 CAPSCREW- Black, 1/4-20 x 5/8" ..... ..... .... .... ................ ............... ................ .............. .................. 1
18 187659 SUCKER BAR ASSY...................... .............. .................................................................................. 1
19 001818 NUT - 1/4-28 ................................................. .................................................................................. 1
20 102467 STUD - Track Cam Roller .............................................................................................................. 1
21 187622 LEVER - Sucker Drive .... ................ .... ........................................................... ................................. 1
22 187645 LEVER · Sucker .................................. ..... ....................................................................................... 1
23 005071 WASHER- I. D. .254 I .252 .............................................................................................................. 1
24 102572 SCREW - Hex Flang:e, 1/4-20 x 1" .. .... ..... ........ ............................................................................... 1
25 101281 PIN - Drive Lock ...... .......................... ........................................................................ ..... .................. 1
26 001094 RINIG - Retaining ..................................................................................................... .......... ............. 1
27 187652 SPRING- Sucker Pivot Torsion ...................................................... .............................. .................. 1
28 187628 LEVER - Sucker Drive Cam, (os) ................................................................................. .................. 1
29 014195 CAPSCREW - Black, 1/4-20 x 5/8" .................................. ............... .............................. .................. 4
30 014249 SOCKET SET SCREW- #6-32 X 3/16, Cup Point ......................................................................... 6

STREAM FEEDER
~
I '-------1
,.----- 2
'------ 6

STREAM FEEDER
Index Part
1 197525 PIN 2
oo • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • •
2 187685 DISTRIBUTOR- Fluff Nozzle ..... 1

oooo•oo•oooooooooo•oo· 00000000000000000000000000. oo•••oooooooo•oo•OO•oooooo• • •oooo o oooooooooooo . . . . . .
3 187686* GUIDE- Fluff Nozzle 2

oooooooooooooooooooooooooooooo•oooooooooooooooooooooooooooooooooo . . .o o o o o o o o o o o o o o • o o o o o o o o • o o · • · o o o o o o o o o o o o • • o o • o o · o o ·
4 197555 SPRING - Compression .. 2

oo • • • • oo.oo • • • oooo • • oo • • • • • • • oo.oooooo.ooo.ooooooooo • • • oo • • • oo • • oooooooo.oooo.ooooooo . . . . . . . . . oo • • • • • • • oo • • oo.
5 102494 RINIG - 0 2
ooooooooo · · · · · o o · o o • o o o o · · · · · · · · o o • o o o o o o o o · · · · o o · · o o · o o o o • · · · o o · · o o · o o o o o o o o o o · · o o · · o o o o o o · · · · · o o • o o o o o o o o o · · · · o o o o o o o o • • oooooo·oo · · · · · ·
6 187119 Nozzle- Fluff ................................................................................................................................... 2

7 187689 THUMB NUT - Flutter Adjusting 2
0000 00000000000 0000 0000000000 000000 0000 0000 0000 . . 0000 000000 00000 0000 000000000000000 00 00000000 00 . . . 00.
8 102495 PIN - Spiral 2

00 0000 0000 . o o . . oo oooo• . o o . 00000 oooo• 000000 0000 . . . . . . 00 00 00000 . . . oo • • • oo. 0 00 00 . . . . oooo • 00000 . . . oo oo oo • 0000 .oo . . oooo • 00.00 . . . . . . . . 00 oo•
9 014249 SETSCREW 1
oooo • • oo.ooooooooooooooooooooooooooooooooooooooooooo oooo ooooooooooo oo OOoooo . . . . oo ooo oo oo . . . . . oo . . . . . . oo.ooooooo oo oo oooo oooooo•oooo.
• = Use Loctite 680

STREAM FEEDER
38
35 1
40 I
, 1 I
41 i 143
1
I
I
I
I
I
\
I I

STREAM FEEDER
Index Part
1 18761 1 MANIFOLD - Frame Head, (nos) ..... .................. .......................... ................ .................................. ... 11
2 187663** SCREW · Adjustment ..... ................ ..... .............. ............... ............... ............................................... 2
3 180472 KNOB ........................................................................................... ................................. .................. 2
4 180780* ELBOW - 90 Degree x 3/8" ............................................................................................................. 2
5 187676 BRACKET - A lignment ..................................................... ................ ........................ ....................... 11
6 101676 CAPSCREW- Black, 10-24 x 3/4" ................................................................... ................................ 2
7 197556 TUBING- Forward Air Nozzle .......................................................................................................... 11
8 112652 SCREW - Phillips, Black, 8/32 x 9/16 ............................................................................ .................. 3
9 187691 PLAT E - Bleeder ................................................. .............. ................ ............................................... 1
10 187612 MANIFOLD- Frame Head (os) ........................................................................................................ 11
11 102040 CAPSCREW - Black, 1/4-20 x 1 1/4" ............................................... .............................. .................. 1
12 014195 CAPSCREW- Black, 1/4-20 x 5/8" ................ ................... ............................................................... 11
13 186473 CLIP - Cord Adhesive .................................... .............................. .................................................... 2
14 187909 SENSOR ASSY. ·Pile Height ............................................ ........................................................... ... 11
15 110113 SCREW- Phillips, 4-40 x 5/ 16" ...... ................ .. .. ......................... .................................................... 2
16 250077 STRAP - Sta ..................................................... .. ............... ................................................. ............. 11
17 197531 PIN ................................ ................................................. ................ ............................................ ... 11
18 197531 PIN ................................................................................. ................ ............................................... 11
19 102562 PIN- Spiral, 1.010 I .990 1/4" Dia ................... .................................................................................. 11
20 187677 DISTRIBUTOR ASSY. ·Fluff Nozzle ............................................................................................... 11
21 197525 PIN ................................ ................................................. ................ .............................. ................. 11
22 001094 RING- Retaining .................................................................... ................ .......................................... 1
23 187782 LABEL- Feeder Head .................................... .................................................................................. 11
24 187675 ROD - Fluff Adjustment ................................. .................... .............................. ................................ 11
25 187661 BRACKET ASSY. - Sensor Fluff Height ............................................................................................ ~
26 197547 SPRING-Compression ........................................................ ................................... .......... ............. 2
27 187660 ROD- Fluff Height Adjustment ......................................................................................................... 11
28 187683 VALVE - Bleeder .................................................................................... ......................... ................. 2
29 102496 SPRING - Wave .............. ................................................................................................................ 2
30 003164 WASHER- Flat, I. D. . 386/ .380 .............................................................. ........................ .................. 2
31 102492 RING - Retaining ............................................ .................................................................................. 2
32 100625 SCREW - Black . 1/4-20 x 1/2" .................................................... ................ ............... ...................... 4
33 187428 PLATE - Support ..... ...................................... .................................................................................. 2
34 187672 BAR - Support ................................................................................................................................. 11
35 101033 SETSCREW - Nylok, Flat Point 8-32 x 1/2" ............................ .... ................ ................... .................. 11
36 102040 CAPSCREW- Black, 1/4-20 x 1 1/4" ............ ................................................................. .................. 11
37 101193 CAPSCREW - Black, 8-32 x 5/8" ...................................... ............................................. .................. 2
38 100891 CAPSCREW - Black, 1/4-20 x 1" ...................................... .................... ......................... .................. 2
39 187671 BRACKET- Support Air ..................................................................................................... ............. 11
40 187673 CHANNEL-SupportAir ................................. ................... ............................................................... 11
41 187642 NOZZLE - Forward Air ...... ..................................................................... ..... ......... ............................ 11
42 102040 SCREW - SHCS ............. .................................................. ........................ ...................................... 1
43 187606 BACKPLATE - Feederhead ........................... .............................. .................................................... 11
44 187684* PIN - Stop ........................................ .... ..... ........ .. ..... ...... ..... .... .... ..... ...... ..... .... ..... ..... ....................... 2
45 187684 DECAL- Arrow (Not Illustrated) ...................................................... .............. ................................. 1
* = Use Loctite 680

=
** Use Permabond

STREAM FEEDER
12 - - - - - - - .

STREAM FEEDER
Index Part
1 014158* SCREW - Black, 10-32 x 1/2" ..... oo • • • oo oooo • oo • · · • • • • oo oo · · · •oooo • • • • oo••oo• • o o · · · · · · · • • • oo • • oo .oo • • oo • • • • • • • • • • • • • • • • • oo•· • • oo • • • oo. 1
2 197309 TUBE ..... oo . oo• o o · · · oo · · · · · oo· oo · · · oo · · · · oo . oooo • oo• • o o • o o · · · · · · o o · o o · · · oooo · · · · · · o o · • o o o o o o · · · · · oo · · · oo oo oo · · · · oo · · oo oo . . . . . . . . . . . . oo oo oo • • oo . . . . 1
3 196971 ** FITTING- Male ... oo oo oo oooo oo • ·oo oo oooo• oo oooooo •oo oo • oooo• oo · oooooo•oo•oooooooooooo oo• oo · oooooooo· oooooooooooooo•oo . . . oo . . oo oo oo oooo oo oo · · o o · 1
4 197528 NUT oo oooo oo . oooo • • oo • • • oooooo. oo o o . ooo oo.oo.oooooo.oooo.oooo. oo . oooo ooooo oo oooo.oooooooo.oo.oo.oooo • • oo . . . . oo oooo • • oooooo. oo oo oooooooo oooo . oo . .. oo. 1
5 197529 CONNECTOR .oooooo . oooo •OO ooooooooooo oo oooooooooooo. 00 00 00 00 •oooooo oooo•oo•oooo oo · 0000000 000 0000. oooooooo•oooo oo ooooooo oo oooo o oo . . . oo oo · o o · 1
6 187695 PLATE· Cover oo••oooo • oo oooo ooooooooooo oo •oooooo oo oo•oooooo oo oooooooooooooooo•oooooooo oo• •oooooooooooo o oooo•oo oo oooo•oooo oo oooo oo oo oo oooooooo 1
7 102356* SCREW- Black Oxide, 10-32 x 1/2" oooooo . . oooooooooooooo . . oo . . oooooooo . . oooo . . oooooooo . . ooooooooooooooo . . oooo oo oo . . . oo . . oooooooo . 3
8 197310 TUBE oo • oooo . . oo oo• oooooooo . . oo oo ooo oo oooooo• oo• oo oo oooooooo . . . . . oo. oooooooooooooo oooo ooooooooooooo • oooooooooooo oo . . . oooo . . . oooo • oooo oo oo oo . . . oo.oo 1
9 187693 PLATE - Manifld Cover . o o 0000.00 00 00 00 00 . . 00 00 00 . . oo . . . 00 . . . 00 00 . . . 00 . . oo . . . oo . oo. 00 . . oo . . . oo . . . . 00 .oo 00 . . oo. oo • • oo 00 00 00 oo . . oo o o . 00 oo . 00 1
10 197557** VALVE - In line Check .. oo . . oooo 000000 0000 00000000. oo oooo oo. 00 0000.0000 0000.0000.000000 0000.0000 0000000000 00 0000 00000 0000.0000 0000 oooo . . . oo 1
11 197525 PIN oo oo• oooooooo • oooooooo oo . . oooo oo oo oo•oo•oo oo ooo oo oo oo oooo oo . . . oo.oooo•oooooooooo oo• ooooooooooooooooooooooooooo • oooo•oo . . . oo oooo oo oo . . oo• OO• oo oo• 1
12 187694 MANIFOLD- Air Supply 000000000000 . 0000 00 0000000 000000000 oooooo• ooooooo oo • oo oo oooo••oooo•oooo• ooooooooo oo oo•oo . . oooo oo oo oo• oo . . . . . . oo.oo 1
=
* Use Loctite 242 (removable)
•• = Use Teflon Tape

STREAM FEEDER

STREAM FEEDER
Index Part
1 187610 BACKPLATE - Separation Unit ...... .............. ... .. ............... ......................... ..................................... 1
2 187616 SCREW - Head Clamp ... ............... ..... ...................................... ...... .............................. ................. 1
3 187458 KNOB- W/Setscrews ..................... ................................................................................................. 1
4 187618 INSERT - Guide .............. ............... ..... ................................................... .... .................... .................. 2
5 187617 BAR - Headclamp ........................ .......... ......................................... ........................ ..... .................. 1
6 187785 SCALE ......................................................... ................................................................................... 1
7 187453 GUIDE - Head ................................................................................................................................ 1
8 187619 NUT - Head Clamp ........................ ......... ..... ................................... ............................................... 1

STREAM FEEDER
1
I
I
I
~1
I

STREAM FEEDER
SHEET SEPARATION UNIT MOUNTING
Index Part
1 187458 KNOB - W2 Set Screws .oo • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • . • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • oo . . . . 1

2 187455 SCREW - Head, Adjustment 0000 oooo. 0000 0000 . . oo. oooo•. ooooooooo• oo•. oooooooooo• • • • • • • 00000000.0000 oooo• . . oo . . 00 . . . 0000 . . . . . oo• 00 oo•. 1
3 187452 BLOCK HEAD GUIDE - Connecting 000000 . . oo . . oo . . 0000 . . 0000000000000 . . oo . . · oooooooo· . . oooooooooooooo . . . ooooooooooooooooooooo•oo 1
4 187454 SUPPORT - Nut-Head .......... oo • • oo • • oooo• 0000 . . . . . . . oo. 000000 .oooo. 0000 oooo • • • o o . 0000 • • oooo • • oo. 0000 .oooo .00 . . 000000 .oo • • • • • • oo • • • • oo 1
5 187459 NUT & PIN ASSY.. oooooooooo . . . . . . . oo . . oo oo oo o o · · · · o o ·oo oo oo . . · · o o · · · oo oooo oo . . . oo . . . . oooo oo ooooooooooooooooo•oo·oo·oooooooooooooooooooooo • • 1
6 102040 SCREW- Socket, Black, 1/4-20 x 1/2" oooo . . oo oooo oo oo oooo oooo oooo oo oo . . . . oo . . oooooooooooo oo oooooooooo . . . oooooooooooooooooo oo oooo 4

STREAM FEEDER

STREAM FEEDER
STREAM FEEDER AIR HOSE ASSEMBLY
Index Part
1 197530 CONDUIT- Flexible, 45" ................................................................................................................ 1

2 197529 CONNECTOR .............................................................................................................. .................. 2
3 187732 BRACKET - Feeder Air Hose (nos) ................................................................................................. 1
4 102418 SCREW- Socket, Black, 1/4-20 x 1/2" ........................................................................................... 5
5 187734 BRACKET - Incoming Power (nos) ........ ................... ...... ........... .................................................... 1
6 254530 MOUNTING STRAP - Universal ..... ............... .... ......... ........... .... ................................................... . 4
7 102553 SNAP - Rivet Plastic ...... ...... ............................................ ............................................................... 4
8 197528 NUT ................................................................. ....... ..... .... ..... ........... ............................................ ... 1

STREAM FEEDER
r--- 5
21 ~
'

STREAM FEEDER
ASSEMBLIES ON FRAME (NOS)
Index Part
1 102318 SCREW · Black, 10-32 x 3/8", #36 8

oo • • • • • • • • • • • • oo . . . . . . o o . o o • • o o · · · · · · o o · · · · · o o • o o • • o o o o · · · · · o o o o • • • oo • o o · · · · oooo • o o · · · · · · · · o o · · · ·
2 000666 LOCKWASHER .................................................... ........................................................................... 8

3 187731 BRACKET- Double, Feeder Control nos ....................................................................................... 1
4 180961 GAUGE- Vacuum .............................. ............................................................................................... 1
5 180959 MOUNT - Gauge Feeder ........................................... ...... .... .... ........... .......... ............ .. ..................... 1
6 179815 BARB - 10/32 X 1/16" 1
oo oooo oooooooooooooooooooooooooooooooooo •oooooo oooooo oooooooo oooo oo . . oooooooooooooooooooooo oo ooooooooooooo oooooooo ooooo
7 178407 TUBING . oo oooo o oooooooo oo • • 1

ooooooooooooooooo ooooooooooo oo oooooooo • • oo. oooo ooooooooooo oo ooooooooooooooooooooooooooooo oo oooooooooo o oooo o ooo oooo • o o ·
8 102184 RING - Retaining, Black 7/8" 1

•ooooo oooo oo oo oo oooo o oooooo• · oo •ooooo oo ooo oo oo oooo . oooo • • o o o o • • oo oooooo . . . oo . . . oo . . . . . . . oooo ooo oo oo oo . . o o • ·
9 180775 ELBOW - 90 Degrees x 5/8" oo • • • • oo 00 00 . . 00 . 1

oo . . . . . . . . . . oo. oo . . . . . . . . . . . . . . . . 00 . . . . . oo . . . oo . . . . . 00 . . . . . . . . . . . . . . . . 00 . . oooo • • oo . . . . . . 0 0
10 180776 ELBOW - 90 Degrees 00 00 00 oo . . . . 00 00 00 00 00 . . oo . . 00 . . oo 00 oo . . . 1

00 00 00 00 00 . . . . . . 00 00 0000 . . 00 . . . . 00 00 00 00 . . . . . . 00 00 oo . . . . 0 0 . . . . 0 0 0 0 . . . .. . 0 0 . .
11 180772 BODY - Valve ...... 00 oo . . . . oo . . oo . . . 00 000000 . . oo . . . oo. 0000 . . . . . . . . . . . 1

000000 . . oo oo . . . 0000 oo . . . . . oo . . oooo• . . oo. oo . . oooo• oo• . . oo . . . 0000 00 00 . . oo. 00.
12 102418 SCREW · Socket . 0000 0 00 . . . . . 000000 oooo• . . oo. oo oo• 0000 00 . . . . . .. . . . 4

oo . . . . . oo. 00 00 . . 00. oo . . . . . . . . . oo . . . . . oo . . . . . oooo• oo• . . . 0000 oo . . . . oo oo . . . oo•
13 174049 LINEFILTERASSEMBLY 1
oooooooooo . . . . . . . . . oo.oooo• oooo · · · oooooo ooooooooooooooooo . . . . . oo . . . oooo . . . . . . oo . . . oo . .. . . . . oooo o oooo oooooo oooo • •
14 254170 NUT- Lock 1

oooooooo••oooo • oo•ooooooooooooooo o oo oo ooo oo oo oo oo oooo oo ooo oo ooo oo oo oooo o oooo ooo oo oo oo oo o oooooooooooooooooooo . . oo oo ooo oooo oooooo oo• oo ·
15 001731 LOCKWASHER ............................... ..... ......... ... ... ..... ..... ........... .... ........................... ....................... 3
16 102418 SCREW -Socket, Black, 1/4-20 x 1/2" 0000 . . 00 0000 . . 00 00 00 5oooo oooo oooooo . . ooooooo oo . . oooooooooooo oo oooo oo o oooo oo . . oo . . oo oo oooooo.
17 187734 BRACKET- Incoming Power nos 1

oo oooo oo oo oo oooooooo oo oooo oo oo oo oo oo . . oo o oooo . . . oooooooooooooooo oo . . ooooooooooooo oooooooooo oooooo•
18 254171 RING - 0 1
oo oooo o oo ooooooooo o ooooooooooooooo oooo oo ooo oo oooooo oooo · oo · o o • oo ooo oo ooo oooooooo ooooo • • oo.ooooooooooo . . . oooo oo•oo . . . . oo ooooo oooooo . . . . oo.
19 254080 CONNECTOR - Cord oo• oooo• 0000 oooo• oooo· oo• 00 000000 . . oo • • 1
00 000000 0000 000000 oooo• 00000 0000 0000.000000 oooo · 0000.00 00 0000 . oooo • oo• 00. . 0000
20 172075 SEAL • Hole oo. 00 00. oo. 00 000 00 000000 00000000.0000.0000 000000 oooo · . oo. 1
0000.0000.0000.000000 0000.0000 0000.0000.000000 00 00 00 00 0000 . 0000 00 00 0000 . 0 0 .
21 187479 STANDOFF oo• o o · · · · · · · · · · 4

oo· oo · · · · · · · o o · · · · o o o o • o o · o o · · · · · o o · · · oo oooo · · · · oo· · · · · · oo · · o o · · · · · · · · o o · · · · · o o o o · · · · · oo · · o o · oo . . . . . . . . . . . . oo. oo • • oo • •
22 253915 SWITCH - Power, 40 Amp. 1

oooo . . oo oooooo . . oo oo oo oo oooooo • • oo . . oooo oo oo oooo . . oooo oooooooo . . . . oo oooooooooo . . oooooo o oooo . . . . oo . . oooooooooo.
23 101091 CONNECTOR o o . oo. 00 • • oooo 0000.0000 000000 0000 oo. 2

00 000000 00 00 00 0000 00 00 0000 . 0 0 0 0 . 0000 00 0 0 0 0 0 0 0 0 . 0 0 0 0 00 0000 0000 . 0000.00.00 0000 0000 . 00 00 00.0000
24 197326 SPRING - Comp oo• oo• • oooo oooo• 0000 oooo• oooo • oo oo• oo oo• 0000 oo• · oo · oooo• 1 00 0000 00 00 00 00 oooo• . . oo. 000000 oooo• . . 00. 0000 oo• . . oooo • 00000000 00 00.00.
25 101876 PIN - Roll 1

oo oo oooooooooooo . . . . oooooooooooooooooooooooooo oo oooooooooo ooooooooooooooo . . . . . ooooooooooooooooooooooooooooooooooooooooooooooooooooooooo . .
26 180472 KNOB 1
oo oo oo oooo o oooo oooo o oo o ooooooooooo••ooooooooooooooooooooooooo·· · oo•oooooooooooooooooooooooo . . oooooooooooooooooo o ooooooo oo ooo oo oooo . . . . . . . . oo . .

STREAM FEEDER
5~
, - - - 13
~-- 11
21 -
18 ' - - - - - 16

STREAM FEEDER
CONTROL BRACKET ASSEMBLY

Index Part
1 253822 SWITCH ............. .................... ............... ........... ......................................................... ....................... 1

2 101031 SCREW - 6·32 X 3/4" ........ ................ ............. .............................. ...... .......... .... ........... .................... 2
3 001731 LOCKWASHER ........................................................................................................ ....................... 4
4 102418 SCREW -Socket, Black, 1/4-20 x 1/2" ....................................................................... .................... 4
5 254766 ACTUATOR ..................................... ..... ...... ..... ................... ......... ............................ .. ..................... 1
6 180472 KNOB ................................ ............... ............... ..... ........................................................................... 2
7 187746 BRACKET- Control Mtg ........................... ............ ........................................................................... 1
8 254756 SOCKET - 32 Pin ............................ ........... ..... ................... ........... .... ......................... .................... 1
9 197387 NUT - Square ........................................ ........ ............................ ...................................................... 2
10 180961 GAUGE- Vacuum ........................................................................................................................... . 1
11 187749 MOUNT · Gauge Registration .................... ..... ................................................................................ 1
12 180780 ELBOW - 90 Degree x 3/8" ............................. ................................................. ............................... 1
13 178775 SPRING - Compression ....... ................ .......................................................................................... 1
14 180778 ELBOW- 90 Degree Street .............. .... ...... ..... ................................................................................ 1
15 180771 VALVE · Relief Vacuum ................... ..... .......... .. ... ......... ...... ...... ..... ......... ..... ................................... 1
16 172812 RETAINER- Nut ................................... ............... ............................................................................ 1
17 102157 SCREW · 10-32 ................. ............................ ........... ....................................................................... 5
18 187748 BRACKET - Gauge Mounting ........................... ....... ................................................ .. ..................... 1
19 180783 GAUGE- Nut ...................................................... ............................................................................ 1
20 001726 WASHER ........................................................................................................................................ 1
21 187906 SPEED POT ASSEMBLY - Conveyor Fan .. .... ..... ...... .................. ...... ...................... .. ..................... 1
22 187783 LABEL - Vacuum Controls ..... ............... ..... ............... ...................................................................... 1
23 187565 Plate, Switch ...... ........................................................ ...................................................................... 1

STREAM FEEDER

STREAM FEEDER
STREAM FEEDER CONVEYOR BELT TENSION HARDWARE
Index Part
1 102549 SCREW· Hex Flange, 1/4-20 x 21/2" ············oo·••oooo······oo···oo·····oo•oo••oooo·····oooo······oo····oooo•oo·············· 2

2 003578 NUT · Hex ........................................................................................... oo • • • • • • • • • • • • • • • • • • • • • • • • • • • oo.oooooo . . . . . . 4
3 187472 ROLLER ASSY- Tensioning .. oo . . ooooooooooooooooooo . . .oo • • ooooooooooooooooooo•oooo•oooo•oooooooo•oooooooooooo . . . . . oooooooooooooo . . . . 1
4 102555 SCREW- Hex Flange, 1/4-20 x 1 1/4" ...... oo . . . . oo . . . . . . . . . . . oo . . . . oo . . . . . . . . . . . oo . . oooooo . . oooo.oo.oooo . . . . . oo . . . . . oooo • • oo • • oo 4
5 187445 SCREW - Conical Head 0000 . . . . . . 0000 00 0000 . . . 000000 oo oo oo · oo . . oooo 000000 00 00 . . 000000 . . 0000 . . . oooooo . . oo . . . . . 0 0 . . . . oooooooooooooooooo . . . . 2
6 187444 BRACKET- Conveyor (nos) oooooooooooo oo oooooooo•oo . . . . .oo.ooooooo oooo oooooooooooooooooooooooooo oo ooooooooo•oo·· · ooooooooooooooooo••oo 1
7 187443 BRACKET- Conveyor (os) oo . . . oooooooooo . . . . oooooooooooo ooooooo oo oooooooooooooooooo • • oooooooooooooooooooooo ooooooooooooooo o oooooooooooo 1

STREAM FEEDER

STREAM FEEDER
DRIP PAN AND CONVEYOR AREA
Index Part
1 187779 GUARD- Stroker Bar ..................................................................................................................... 1

2 187750 PAN- Drip ....................................................................................................................................... 1
3 187751 PAN- Drip ........................................................................................................................................ 1
4 102405 SCREW .......................................................................................................................................... 2
5 187430 CONVEYORASSEMBLY ........................ ...... .................................................................................. 1

STREAM FEEDER
.. 3
4
11 ....
'
10
:~-.. ~ ...........
/
7

STREAM FEEDER
STREAM FEEDER CONVEYOR ASSEMBLY
Index Part
1 102394 SCREW- Black, 10-32 x 1/4 #36 ................................................................................................ .. 4

2 700018 SCREW- #2, (Max 8 mm) .............................................................................................................. 3
3 187434 BELT - Conveyor ..... ....................................................................................................................... 1
4 187436 CONVEYOR - Sub Assembly ................................................................................... ...................... 1
5 700149 NUT - Hex, (M8) .............................................................................................................................. 1
6 700134 WASHER ........................................................................................................................................ 1
7 187927 CONVEYORVACUUMFANASSEMBLY ........................................ ..... ........................................... 1
8 187472 ROLLER ASSEMBLY -Tensioning ..... .... .................... .... ..... ...... ...... .............. ................................ 1
9 187468 PLATE - Fan Support .................................... ............... .................................................................. 1
10 190646 SCREW - Shoulder .............. .............................. .............. ..... ......................................................... 1
11 054437 SPRING ................. .......... ......................... .... ................. ..... ..... .... .... ................ ............... .............. .. 1
12 187469 VENT PLATE - Conveyor .. ............................................................ ............................ ...................... 1
13 187447 LOWER ROLLER ASSEMBLY .......................... ............................................................................. 1
14 187791 SCALE - Vacuum Conveyor ........... .............. ................ .... ..... .......... ............... ................ .............. .. 1

STREAM FEEDER
..-1
/ I
I
I
L. . . .
~~
I
I
I
I
I
I
I
I
I
I
I
t/

STREAM FEEDER
STREAM FEEDER SHEET GATE ASSEMBLY
Index Part
1 102469 BUSHING - Thrust, Sleeve .... ........... ................ .................. ............................................................ 2

2 102468 BUSHING - Sleeve, 3/4" .... ......................... .......................... ........ ..... ........... .... ............................... 2
3 102461 BUSHING ....................................................... ................................................................................ 3
4 187547 HOUSING - Bearing, Sheet Flap .... ............................................ ..................... .............. .......... ...... 2
5 014219 SCREW .................... ....................................... .......... .......... ............... .......... ..... ....... .. ..................... 2
6 187541 SHEET FLAP ASSEMBLY ................ ............... .. ... ....................................... .................... ................ 1
7 197160 COL LAR- Shaft ........ ............................................ ........................................................................... 1
8 187561 SHAFT ............................................ .......... ...... ......... ......................... .............................................. 1

STREAM FEEDER
' - - - - 27

STREAM FEEDER
INFEED AND SHEET GATE CAM ASSEMBLY
Index Part
1 102467 ROLLER - Track Cam Stud ............... .......... ................................................................................... 1

2 197026 PIN -Dowel ...... .............. ............... ............... ................... .............................. ................................. 1
3 150085 NUT - Lock .......................... ........................................................................................... ................. 1
4 014219 SCREW - 20 X 3/4 .................................................................................................... ......... ············· 3
5 0 14562 ANCHOR - Spring ... ....... ........................................ ........................................................................ 1
6 102466 ROLLER - Track Cam Stud .................... .......... ........... .... ............................................................... 1
7 187562 LEVER - Cam, Forwarding Wheels ... ............................................................................................ 1
8 187564 LEVER - Over-Travel Switch ........... .......... .............. ...... .... ..... .... ...... .............................. .............. ... 1
9 102418 SCREW - Socket, 1/4-20 x 1/2" ... ..... ......................... ........... ....... ... .................... .......... .................. 1
10 001818 NUT- 1/4-28 ..... ................... ............... .......... .................................................................................. 1
11 001991 PIN - Drive Lok ........ ...... ..................... ......... ..... ...... ..... .................... .............. ................ ................. 1
12 190712 SPRING- Extension ....... ................ ......... .... ...... ......... ........................................ ........... ................. 1
13 187544 BRACKET ....... ................ .................... ..... ....................................................................................... 1
14 102307 PIN - Drive-Lok ................. .............. ..... ........ ..... ...... ........................................ ............... ............... .. 2
15 197474 SPRING· Extension ....................... ............. ...... ......... ..... .......... ............... ..... ................ ................. 1
16 187552 PIN - Shoulder .. .............. .................... .......... ..... ............................................................ ................. 1
17 187553 COLLAR - Eccentric ....... .................... .......... .............................. ..... .............. ............... .................. 1
18 195837 WASHER ................. ....... .............. ..... ................ .... ..... ..... ...... ............................. ......... ................... 4
19 190713 PIN ................................ .......... ............... .......... ............................................................ ................. 1
20 0 14515 O·RING ........................... ............... ......... ............................................................ ................ ............ 2
21 187554 BRACKET ....................... ......... ..... ...... ........ ...... .......... ..... ..... ............................. ............... .............. 1
22 187907 SOLENOID ASSEMBLY- Sheet Gate .... ................................... ............... ...................................... 1
23 100546 SETSCREW ..... ....................................... ........................................................... .............. .............. 2
24 187526 HUB - Cam ...... ............... .......... ...... ......... .... ........... ....................................................... ............... .. 1
25 187529 CAM - Forwarding Wheels ............ .................................................................................................. 1
26 187527 SPACER - Cam .............................................................................................................................. 1
27 18751 8 CAM - Sheet Gate .... ...................... ............................................................... ...... .............. .............. 1
28 197026 PIN - Dowel .................... ............... .... ................................................... ............................ .............. 1
29 102523 KEY - Square .... ....... ........ .... ........................ ........... ..... ..... ............... ......... .................... ..... ............. 1
30 102040 SCREW- 1/4-20 x 1-1/4" ............................. ................ ..... ............................................. ................. 4
31 187551 LATCH - S.F. Solenoid ....................... ...... .......................................................... ................ .......... .. 1
32 197519 SPRING - Extension ....... ..... .............................. ......... .............................. ........................ .............. 1
33 253822 SWIITCH- Overt ravel ...... .............................. ............... ....................................... ................ ............ 1
34 10 1031 SCREW - #6 X 3/4 .... ....... .............. ............... ..... ................................... ........................................... 2
35 250493 CABLE TIE ............... ....... .......... ..... .... ........... ..... ..... .... ................ ..... ......... ........... ........................... 1
36 187168 SHIELD - Solenoid ......................... ................................... ................................. ........... ................. 1

STREAM FEEDER
'---- 4
.....___ _ _ 5
.....___ _ _ _ 6

STREAM FEEDER
CROSSBAR ASSEMBLY
Index Part
1 187769 KNOB .. ............... ............................................. ......................................................... ....... ................ 4

2 102387 SCREW· Black Oxide, 10-32 x 1/2", #36 .......... ........................................................ .................... 2
3 187410 BAR - Spacer, Rectangular ............................. ................................................................................ 1
4 187759 RAJ L · Center Feeder ....... ................ .... ......... ... ........................... ........... .... ............... ..................... 1
5 102405 SCREW · Hex Flange, 1/4-20 x 1/2" .................................... .............................. .............................. 1
6 187760 SPACER ............ ............... .................................... ........... ..... .... ....................................................... 1
7 197449 BOLT- Eye (2.5} ............... ..... ............... .... ........... ...... ......... ................ ............................................. 4
8 187407 ROLLER ASSEMBLY · Lower ......... ........... .... ........... ..... ...... ......... ......... ...... ................................... 1
9 187761 COVER - Lower Rear Feeder ........................ ....... .............. .......... ...... .............................. .............. 1
10 102405 SCREW- Hex Flange 1/4-20 x 1/2" ...... ...... ........ ...... .......... .............................. .............................. 2
11 102381 SCREW · Black Oxide, 10-32 x 5/16" ............. .......... ...... .......... .................... ..... .............................. 2
12 187762 COVER - Upper Rear Feeder ......... .... ............. ............ ..... ..... ........... ..... .... .... ........... ..................... 1
13 102535 SCREW - Shoulder Bolt, 3/8-16 x 5/8" .......................................... .......... ........................................ 2

STREAM FEEDER
~- 35 , 39
r------2
21 - - _ J ..---3

STREAM FEEDER
STREAM FEEDER FEEDING HARDWARE PART 1

Index Part
1 187461 STRAP- Short ..... ............................................. ....................................................... ....................... 2
2 172237 STRAP - Hold Down .................................................................................................................... ... 5
3 172236 BRACKET - Hold Down ............................................................. ..... ..................... .... .................. ..... 7
4 000666 WASHER- Lock ......................................... ............... ........... .... .................... ............................. ..... 2
5 187779 GUARD Stroker Bar .................................... ................................................ ................................... 1
6 102418 SCREW- Socket, Black, 1/4-20 x 1/2" .. ........................ .......................... ....................................... 2
7 001106 SCREW - Phillips .......................... ............................. .... .......................... .... ....... .......................... 14
8 065361 THUMBSCREW .. ......................... ................................................................................................... 7
9 172352 STRAP ASSEMBLY- Guide ....................................................... .......................... .... .... ................... 1
10 187583 GUIDE ROD - Medium ............................... ................ ........................................... ......................... 2
11 187582 GUIDE ROD - Short ......................................... ..................... .......................................................... 2
12 187800 DOUBLE SENSOR ASSEMBLY .. .................... ..... .......... ................................................................ 1
13 102345 SCREW- Black Oxide 10/32 x 1/2" ............ ......................................................... ........................... 2
14 180472 KNOB ......................................................... .................... ...... ..... .............. ................... .................... 2
15 187577 COLLAR- Locking .................................................................. ................ ....................................... 1
16 187571 SHAFT - lnfeed Roller ......................................................................................... ........................... 2
17 173716 ROLLER ASSEMBLY ................... ....................... ...... ..... .... .......................... ....... .. ......................... 2
18 014697 WASHER ............ ....................................... .......................... .... ........... ............................................ 4
19 187573 SCREW- Adjustment, lnfeed Roller .............................................................................................. 2
20 192035 SPRING - Compression ............. .......... ...... ......... ..................... ..... ................................................ 2
21 187575 ARM - lnfeed Roller .................................... .......................... ......... ...................... ........................... 2
22 187574 HOUSING - lnfeed Roller .............................................................................................................. . 2
23 014219 SCREW- 1/4-20 X 314" ................................................... ................................... ............................. 4
24 187572 HOUSING - Pin, In feed Roller ........... ...... ........ ....................................................... ........................ 2
25 021861 WASHER ............ ................................................................. .... ........... ..... .............. ......................... 2
26 187898 SENSING LEVER - Paper Pile ...................................... ................................... .......... .................... 1
27 187899 CLAMP - Sensing l!..ever ................................................................................................................. 1
27A 014219 SCREW .......................................................................... ..................... .............. ............................. 2
28 187786 SCALE - Head Height .................................................................................. ............................... ... 1
29 187782 LABEL - Feeder Head .................. .............. ............... ..... .............................. .................................. 1
30 197559 KNOB ................................................................................... ..... .... ...................... ... .... .................... 1

STREAM FEEDER

STREAM FEEDER
STREAM FEEDER FEEDING HARDWARE PART 2

Index Part
1 18735 3 STRIPPER FINGER ........... .......... .... ........... .......... .... .............................................. .... ................... 2
2 187769 KNOB .................. ............... ......... ..................... ..... ......... ..................... .... ................... ................... . 4
3 187654 SUCKER FOOT .... ......................... .................. .......... ............... ...... ......... ................ ....................... 1
4 187653 SUCKER FOOT .... ......... ..................... ............. .......... ..... .......... ..... ...... .... ..... .................................. 1
5 187369 ROLL ROD ASSEMBLY ....... ......... .................... .... .......... ..... ...... ..... .... ................. ........................... 2
6 187255 CLAMP SCREW ............. .................................. ..... ...... ......... ................ .................................. .... . 2
7 187257 ROD BLOCK ..... ........ ............... ..... ......... ................ .... ............... ...... .............. ... .. ......................... 2
8 01 4372 SETSCREW .... ......... ..... ........... ..... ......... .................... .... ........... ..... ..... ..... ............... ................... 4
9 187256 ROLL ROD .. ..... ......... ............... .... ..... ................ ........ ........... ...... ......... .................... ................... 2
10 187354 BACK STOP ASSEMBLY .................. ................... ................ ..... .... ................ ....... .. ......................... 2
11 187861 CLAMP - Backstop ............ .......... ..... .... .......... .......... ...... .............. ...... ....................................... .... . 2
12 172266 KNOB ........... .............. ..... .......... .... .......... ...... ..... ......... ................ ..... .... ................... ................. .. . 2
13 187862 BACKSTOP .................... ................ ......... ................ ..... ..... .... .......... ............... .. ........................... 2
14 100501 SCREW ........ ..... .............. ................ .............. .......... ..... ......... ................ ..... .... ............................. 4
15 187299 PLATE - Strap ............ ..... .............................. ......... ........... .... ..... .... ..... .................... ................... . 4
16 187254 STRAP - Hold Down .. .............. .......... ...... .............. .................... .......... .................... ................... 2
17 187267 BRACKET ........ ..... ............................. ........... .... .......... ..... ...... .... ..... ............... ...... ....... ................. ... 2
18 102157 SCREW ......... ..... ............... .......... ..... ........... ............... .... .......... ...... ......... .................... .................. . 1
19 021861 WASHER ....................... .... .......... ...... ............................. ..... .... ..... ........... ......... .......... .................... 1
20 0142 19 SCREW ......... .................... .................................... ..... .... .......... ...... ......... ............ .... .... ................... 1
21 187355 FEED ROLLASSEMBLY .... .......... ............... .... .................... ...... .... ..... ................ ............................ 1
22 187576 CLAMP - lnfeed Roll Assembly .... .... .......... ..... .................... ........................................ .................. . 1
23 0142 19 SCREW- #2 .................. ..... ........................ ......... ...... ..... ......... ..... ........... ....................................... 1
24 173716 ROLLER ASSEMBLY ......... .......... ..... ......... ............... ........... .... .......... .......... .... ... .. ......................... 1
25 187575 ARM - lnfeed Roller ....... ..... ........................ .... ........... ..... ...... ..... .... .......... ..... .............. .................... 1
26 187441 HOUSING - lnfeed Roll ..... ........... .... ................... .......... ...... ........... ........ ............. ........................... 1
27 187262 PIN - Pivot ...................... ..... ........... .... .... ...... ............................. ........... .... ............ ... ........ .. ...... .... .... 1
28 187259 TUBE - Long .................. ..... ............................. .... ...... ........... .... ...... .... ........................ .................... 2
29 187258 TUBE · Short ................. .............. .... .......... .................................... ............................. .... ............... . 1
30 174030 FEEDER ROLLER ASSEMBLY - O.S . ......... ........................ ..... .......... ..... .......... ............................. 2
30A 174032 FEEDER ROLLER ASSEMBLY- N.O.S ................ .... ..... .......... .... ..................... .. .. ......................... 2
31 179232 CLAMP - Pressure Roller ......... ..... .......... ..... ......... .................... ...................... .... .... ................... 2
32 172266 KNOB ........... .... .......... ..... ...... .... .... .......... ...... ..... .... .......... ...... .......... .... ............... .... ................. .. . 2
33 197000 BEARING ... .............................. ............... ........... .... .......... ...... ............. ............. ....... ............... ..... 2
34 196849 SCREW ............. ............. ........... .... ..... ............... ..... ..... ............... ..... .......... .................................. 2
35 014713 WASHER ........ .......... ..... .... ........... ........... ........ ........... ..... ........... .... ......... ...... ......... .................... 2
36 150083 LOCK NUT - #8 ............... ......... .......... .......... ............... ...... ..... ..... .... .... ...... ..... ......... .................... 4
37 179234 BRACKET ................. ...... ......... ................... ........... ..... ..... ...... .... ......... ...... .................................. 2
38 179233 ARM - Short ................ ..... ........... .... .... ..... ...... .............. ......................................... .... .............. ..... 2

STREAM FEEDER
SECTION A-A
19---
1 8 -.......
17
2
16 _ _.:....:....._____:....:._,
15 ---T""T-------1-r--'
14
14
13 .._--12
3

STREAM FEEDER
DOUBLES SENSOR ASSEMBLY
Index Part
1 100696 SCREW - Phillips Button Head ...... ...... ......... ............................................. ............ .. ..... ................. 4
2 187816 SPACER - Switch ............ ..... ........... .................. ................ ............... .............................................. 1
3 150083 LOCKNUT - 10-32, UNF .................................................................................. .............................. 1
4 187808 PIVOT ............... ............... ....................................................... ................... ................................... .. 1
5 187818 PLATE - Cover ............................... ...................................................... ..................... ...................... 1
6 187911 SENSORASSEMBLY .................................................................................................... ................. 1
7 250560 STRAIN RELIEF ..... ........................................................................................................ ................ 1
8 041291 SPRING - Tension ......................... ......... ...................................................................... ................. 1
9 187819 SCREW - Insert 1/4-56 ........................ .......................................................................................... 2
10 0 14851 NUT - Flat, 3/8-24 ........................................................................................................................... 3
11 187820 SCREW - Insert ..... ........... ............................................................................... .............. ............... .. 1
12 080578 SPRING - Tension .......... .............................................................................................. ................. 1
13 187801 ARM - SEnsing Lever .......... ........................................................................................... ................ 1
14 187811 LEVER- Adj . ...... .... .............................. ........................................................................... .............. .. 1
15 003268 WASHER ....................................... ................ ..... ............................................................................ 1
16 001060 E-RING .......................................... ...... ..... ........ .............................................................................. 1
17 187813 ADJUSTMENT SCREW - Switch .................................................................................................. .. 1
18 187814 ADJUSTMENT SCREW ............................... .................................................................. ................. 1
19 187806 BASEASSEMBLY .................................... ....................................................................................... 1
20 102345 SCREW · Button Head, 10·32, UNF ............. ................................................................ ................. 4

STREAM FEEDER

STREAM FEEDER
DRIVE SHAFT AND INFEED ROLLER
Index Part
1 187530 ROLLER - lnfeed, DR ....... ................ .... ......................... ..... ......................... ............ .. .................... .. 1
2 014219 SCREW .......................................... .................... .................................................... ....................... 13
3 187539 HOUSING ASSEMBLy OS ..•. ••• ••....•...• .••. •••.•• •.••...........•.•••.••. .•... •..••... •.. •···· .••••..•..••.....••..•••• •.. ....•• .• 1
4 100546 SETSCREW - Pivot, 1/4-20 x 5/16" ....... ...................................................... ............ .. .................... .. 2
5 102557 KEY - .75 X . 188 X . 188 ................. ......... ..................................................................................... .. 1
6 187534 HOUSING ASSEMBILY nos ................. ......... ...... ............................................................................ 1
7 187521 DRIVESHAFT ... .............................................................................................. ................................. 1
8 102457 BEARING- Ball ............................................................................................................................... 3
9 195837 WASHER ......................................... ................... ..... ......................................... .............................. 2
10 197134 KEY- Timing Pulley, 1 3/4" LG ........................... ............... ............................................................. 1
11 102460 RING - Retaining, Black ... ............... ..... .... ...................... ............................................................... .. 2
12 187523 HOUSING- Bearing, Black ............. ..... ......................... ............... ................................................... 1
13 187525 GEAR - Spur, 58T, Main Drive .......... .............. ..... ............................................................................ 1
14 187524 SPROCKET ...... .............. ............... .... ............... ........... ................................................................ ... 1
15 197195 WASHER ................ ........................ ..... ............... .......... ..... ...... ......... ............... ............................... 7'
16 100891 SCREW - Cap ....................... .......... .................... .......... ............... ................................................... 1
17 187514 PULLEY- Main Drive/U-Joint .......... ..... ......... ...... .......... ................................................................. .. 2
18 187513 HOUSING - Bearing, U-Joint ........... .............. ...... ......... ..................... ...................... ....... ................. 1
19 187535 GEAR- Spur, 38T, Conveyor Drive .................................................................................................. 1
20 187434 BELT- Conveyor ..... .......................................................... .............................................................. 1
21 187515 BELT - T iming ... ....... ........ ............................. ................ ..... ............... .............. ........ .. ...... ................ 1
22 187538 SPACER-ConveyorDrive ................... .......... ...... .... ................ ..... ................................................... 1
23 102456 CHAIN-SingleStrand74-1 /2 ................................... ........................................ ................................. 1

STREAM FEEDER
\
\
\
\
\
\
\
\
'I
I
\
\
\

STREAM FEEDER
DOLLY ELEVATOR
Index Part
1 100891 SCREW- Cap, 1/4-20 x 1" o o • o o • o o · · · · · · · · · · · · · o o • • o o · · · · · o o · · · · · · · o o · · · · · · · · o o • • o o · · · · · o o • • o o · · · o o · · · · · · · · o o · · · oooo• • o o · · · · · · · · · · · · · · 12

2 187483 STUD - Idler Wheel ..................................................... 00000 0000 oooo• 00 0000 00000000. oooo. 00000000.00 0000 0000 00000000.00000 6
3 187463 BEARING - Linear oo o oooooooooooooooooooooooooooooooo• 0000000000000000000000000000000000. ooooooooooooooooooo•·oo· ooooooo•oo·oooooooooooooooo 8
4 187829 ELEVATOR ASSEMBLY- nos 00 00 0000 00 oo• 000000 00 00 00 .oo. 00 oo. 000000 00 00 oo• 00 00 00 00000 0000 00 00000 00.00 oo • • 00 00 0000 00 00 oo.oo. 0000 . 00 . 1
5 102503 SCREW - Hex, 1/4-20 ooooooooooooooooo oo oooo • • oo.oooo oooooo ooooooooo•oooo •oooooooooooo · oooo oooooooo ooooooooo oooooo oooooooo oooooooooooo•oo· 4
6 014550 PIN - Driv-Lok Spring ooooooooooooooooooo o oo oooo oooo • • oo. oo oo oooo ooooooo oooo ooo ooooooooooo ooo oooooo oo••oooooo oooooo 00000000 00 000 0000000000· 4
7 187830 LEVER - Dolly Support 00000000 0000000000 000000 00000000 0000 000000000000 0000.000000000 00 000000 00 0000000000.0000 0000 0000000000.0000000000000 2
8 102461 BUSHING ooooooooooo•oo• • oo•oooo•oo•oo•oooooo ooo ooooooooooooooooo ooooooo oooooooo o oooooo oooooo ooooooooooooo oooooo oooooooo •oo•oooo oo ooo ooooooooo • • 4
9 187487 IDLER WHEEL ASSEMBLY oo. 0000 . 000000 00 00 00 00. 00 . . oo . . . 0000 . 00 00 0000. oo . . . oo•oo · ..... 00 0 0 . 0000 oooo . 00000000 .oo oo . . . 000000000000 . . oo 6
10 187755 GUARD - Chain, Lower os .oo 0000 00000000000000000 00 0000000000 000000 00000000.0000000000 000000 000000 00 000000 0000 000000 0000.000000000000. 1
11 187828 ELEVATOR ASSEMBLY - os oooo• oo oo• 00 0000 oooo• . . . . oo . . . 0000 oo oo• 00 00 00000 oooo • 00 0000 0000 00 0000 00 00 oooo• 0000.0000 00 oooo• oooooo• oooo• 1
12 102529 SCREW - Set, 1/4-20 . 00 00 0000.00 oo• 00 00 00 00 oo• 0000 00 . . . 00 oo• oooo• 00 00. 00 00 .00 00 00 00 . 00 00 00 00 oo • 00 00.00 00 00 00.00 0 0 . 0 0 . . . 00 oo • oo . . . . . . . 0 0 00 4
13 020444 SPRING ooooooooooooooooo . . . . oo . . oooooooooooooooooooooooo•oooo o oooo . . oo oooooooooooo oooooooooooooo oooooooooooooooo oooo•oooo oooooooooo ooooooo oo oooo. 2
14 187467 CHAIN -Anchor 000000 0 0000000 . . . oo oooo• 00 00 oooo • 0000 00 0000 . . . . . 0000 00 00 00 oooo • •oooo • 0000 00 oo• 0000 oooo• 0000 00 oooo• 0000.00 . 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 oo. 2
15 003578 NUT - Hex, 1/4-20 . o o . oooooooo•oo•oooo . . . . oo . . . . ooooooo . . . . . . . . . . oo.ooooooooooooooooo•oo·· 0000000000 . . . 00 . . . . . . . . 00 . . . . . . . . . . . . 00 . . . . . . . . . . . . 2
16 102555 SCREW- Hex, Flange, 1/4-20 x 1-1/4" ooooo ooooooooooo• ooooooooooooooooo oo oo o oo oooooooooooooo•oooo•oooooooooooooooooooooooooooo. 2
17 187427 CHAIN -Table Raise/Lower 000000000000000000000000000000000000000000000000000000000 00 000000000000 00 000000000000 00 00 000000000000000 • • 2
18 187754 GUARD - Chain, Upper 00 000000000000000 000 00000000 . . . . oo . . 0000.000000 000 00 0000 oo . . . . . . oo 00 00 . 0 0 0 0 00 0 0 0 0 ooooo 0000 0000 00 0000.00000000 0000. 2
19 100625 SCREW - T94N .. 0000 . . 0000 00 00 00.00 00. 00 00.0000 00 oo•. 00 00 00 0 0 . 00 00.00 00 0000 00 00 oo· 00 00.00 oo• 00 00.00 00 00 00 00 00 oo· 00 0 0 . 0 0 . 00 00.00 00 0000 00 00 00. 6

STREAM FEEDER
I
I
I
I
I
I
tCb

STREAM FEEDER
DOLLY ASSEMBLY
Index Pa rt
1 187495 DOLLY ASSEMBLY ......... ................ ..... .......... .......................... .............. .................. ....................... 1
1A 400900 TOP · Dolly ...... .............. ............... ...... ........... .. ................ ............... .............. ............................... 1
2 187494 BASE · Dolly with Guide .... ......................................................................................................... 1
3 081516 CASTER - Swivel .......... ............... ..... ....................................................... ................................... 2
4 081515 CASTER - Rigid ............................................ ........ ..... ..... ..................................... ....................... 2
5 197185 SCREW - Flathead, 5/16-24 ............................ .............. ........................................ .................... 16
6 014809 NUT- 5/16-24 ................................................... ..... ......... ............................................................ 16

STREAM FEEDER
/ O.S . Frame
'
I
I
I
L------------------------------- ---,l
Q I
I
I
I
I
<I>

STREAM FEEDER
STREAM FEEDER FRAME (OS)
Index Part
1 101483 SCREW - Cap, 1/4-20 x 1-1/4" ....................................................................................................... 6

2 100878 PIN - Roll ........................................................................................................................................ 2
3 187411 RAIL - T-Head Guide ................................................................... ................................................... 1
4 187412 RAIL- T-Stem Guide ...... ................................................................................................................. 1

STREAM FEEDER
/ N.O.S. Frame
~l
_______c:5______
o II
oo I
cb
0
I 0
I
I
L--------------------------------- 0

STREAM FEEDER
STREAM FEEDER FRAME (NOS)
Index Part
1 101483 SCREW - Cap, 1/4-20 x 1-1/4" ....................................................................................................... 6

2 100878 PIN- Roll ........................................................................................................................................ 2
3 187411 RAIL- T-Head Guide ...................................................................................................................... 1
4 187412 RAIL- T-Stem Guide ....................................................................................................................... 1
5 187758 PLATE - Safety Switch ...................................................... .............. ................................................ 1
6 001805 NUT - Hex ......................................... ................ ......................... .............. ...................................... 2
7 102405 SCREW- Hex Flang:e, 1/4-20 x 1/2" ............................................................................................... 2
8 253822 SWITCH ....................................................... .... ................ ................ .............. ................................. 1

STREAM FEEDER
'----- 6

STREAM FEEDER
STREAM FEEDER UPPER TIE BAR ASSEMBLY
Index Part
1 102064 SCREW · Socket, 3/8-16 x 1-1/4" ............... ..... ......................... ....................................................... 6

2 187402 FRAME - Feeder, os ........................ .............. ....... .......... .... ................ ......... ..... ........... .................... 1
3 187403 FRAME - Feeder, nos ...................... ................ ......................................................... ....................... 1
4 187404 BRACE - Spacer .............................. ..... ........................................................ ................................... 1
5 186487 PIN - Round ........ ............... ..... ............... ..... .... ................ ...... .............. ..... ....................................... . 3
6 186488 PIN - Diamond .. ............... ................ .... ......... ... ... ......... ..... ......................... .................................... 1
7 102549 SCREW- Hex Flange, 1/4-20 x 2 1/2" .. ............................................ .............................................. 1
8 003578 NUT- Hex ........... ............... ...... ..... .... ......................... .......... ...... ......... ............................................. 2
9 102300 SCREW - Hex Flange, 1/4-20 x 2" ... ..... ...... ......... .......... ........... .... .................................................. 1

STREAM FEEDER
4,5 ~ ' @
N.O.S. Frame
' @l L
..................
O.S. Frame

STREAM FEEDER
STREAMFEEDERBASE-PART1
Index Part
1 102064 SCREW - Socket HD 38-16 x 1 1/4" 00 oooo• oo•oo • • oo • • • • • oo.oooo • • • • o o • • o o • · o o · ·· · · · · • • • oo • • oo .oo • • oo • • • • • • • • • • • • • • • • • • • • • • • oo • • • oo. 6
2 100891 SCREW - Cap ... 00 0 0 . 000000 00 0000.00 0000 00 00.00 00 00 00 0000 • • oo. 00 00 000000 00 00 00 00 00 0000 0 0 . 0 0 .oo 000000 • • • • oo 00 00 0000000 00.0000 0000 000000 00.00 00 2
3 187491 LOCATING PAD· Feeder ooooooooooooooooooooooooooo•oooooooooooooooooooooooo•oooooo · oooo•oooooooo•oooo•oooo•ooooooooooooooooooooooooooo· 2
4 102570 SCREW- Hex Flange, 5/16·18 x 3/4" oooo . . . oo • • oo . . oooooo • • oo . . oo.ooooooooo . . .oooo.oooooo . . . oo • • oooo . . . . . . oooooooooooooo.oooo.oooo 4
5 014784 WASHER ooooooooooooooooooooooooooooooooooooooooooooooooo•OOOOoo•oooooooooooooooooooooo·oo··oo•ooooooooooooooooooooooooooooooooooooooooooo . . . oo. 4.
6 187496 SHAFT- Guide oo• 0000 oo• oooo• oooo• oooo• 00 0000 00 00 00 00 oooo• 0000 . 0000 00 oooo• 0000 oooo• o o o o • . oooo• oooo• oooo• 0000 oooo• oo . . . 000000 0000 00000000 oooo• 1
7 187493 SPACER- Brace, Lower, Machined 00 00000000000000 0000 000000 00000000000000000000 00000000000000000000 0000 00000 00000000000000000000 1

STREAM FEEDER
23
28 - -
4 --~

STREAM FEEDER
STREAM FEEDER BASE- PART 2
Index Part
1 187406 SHAFT ASSEMBLY - Long, Paper Guide ....... oo • • • 00000 • • • • · o o · · · · oo • • • • oo o 0000 00000 • • • • oo 0000 0 oo • o o · · 00 0000 0 oo • • • • • • • • • • • o • • 2
2 102503 SCREW· Hex, 1/4-20 x 1·1/2" oo oo o o o · · · · · · o · o · · · · o · · · · · · o o · · · · · · o · · · · · o oo• •o oo o o• • o · · · o · · · · o o o o · · · · · ooo • • oo o o o · · · · · o o • • • o oo o · · · · · · · o · 2
3 101756 SCREW. 3/8-16 X 1" · · · · · · · • • o • • • • • o oo o ooooo o ooo o oooo o • • • • • • •o o o o o • • • • • • • • • • o o o o o o • • • • • • ooooo o o o • • • • • • • • • • o o o o o • • • • • • • • • o o o o ooo o ooo o o o • • • · • 4
4 187414 SHAFT ASSEMBLY - Short, Paper Guide • o · · · · · · ·· o · · · · · · · · · · · · · · · · · · · · · · · · · o • • o o o o · · · · · · · · · · · · · o · · · · · · · . o • • • • o • • • • • • • • • • o • • • o . 2
5 187402 FRAME - Feeder, os ...... ............................. ............... ..... .......... · · · · o · · · · · · · · · · · · · · · oo · · · · · · · · · · · · oooooooo oo oo oooo oo . . . 1
6 187403 FRAME - Feeder, nos 000 oo oo· 00 00 00000 00000 000 000 00000 0000 . . .oo. 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 00 000 • • 00000 0000 00 000 oo oo· • • 1
7 187410 SPACER BAR- Rectangular 000000000000000000 00 000000000 • • 000 00 00000000000000000000000000000000000000000000000000000000000 00 000 00 000 . . . 1
8 187407 SPACER BAR - Hex . oo . . . . oo . . . . . . . . . . . . . . . . oo . . . . . . . . . . . . . . .oo . . . oooooooo . . . oo . . oooooooooooo . . . oo.oooo . . . oo . . . oo . . . . . . . . oo . . . oo oooooooo . . . 1
9 187423 BEARI NG - Paper Gu ide Shaft oo oo oo oooo oo oooooooo oo oo . . . oooooo . . . . . . . . o o o o o o o o o o o o · - · o o oo oooooooooooooo . . . . oo . . . . oo . . oooo oo oooooooo . . . 4
10 100119 WASHER- Bowed .... oooooooooooooooooooooooooooo oo ooooooooo o ooo oooo oooooo···ooooooooooo • • oooooooooooooooooo oo oo oo ooooooooooooo oo oooooooo· · · 4
11 187379 SHAFT ASSEMBLY- Table Raise/Lower 0000 00 000000000000 0000 00000000000000000000 00 00000000 00 00 00 0000000 . . 0 0 . 00 00000000 00 000000 1
12 187580 BRACKET - Long Strap .. oo . . . oo. 0 0 0 0 . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . 0 0 000 0 0 0 0 0 0 0 0 0 0 0 • • oo• 00 00. 0 0 0 0 . 0 0 . oo • 0000.00 00 . . . 00 00 oo • oo• . . 00 0000 00 00 00 00 00 . . . 00 2
13 014219 GUI DE NUT ASSEMBLY ooooooo oo oooooooooooooo oo ooooo oo . . .oo. oo ooooooooooooooooooooo • • oo.oooooooooooooooo o oo oo oooooooooooooo oo oo oo oo . . . . 2
14 001093 RING- Retaining 000 000 0 000 00 000 00 0000000 00 00 00 00 000 00 000 00 000 00 000 00 00000000 . . . . . 0000 0000000000 0 000000000 0 0000 0 0000000 00 0 00 00 00000000000000 00 2
15 014195 SCREW · Cap. 0000 000 . . . . oo . oo . . . . . . . . . . oo 0000 0 ... oo . . 00 . . oo . . . . . . . o . . 00 00 . . . . . . . . . . . . . . . . . . . .. .. .. oo . . . . . . . . . . . . 00 00 . . . . . . . 00 . . . . . . . . . . . . . . . . 3
16 187882 BEARI NG- Elevating Shaft oo . . . . . . . oooooo . . . . oooooooo . . . . . oo .ooooooooooooooooooooooooooo oo oooooo oo ooooooo . . . . . . . . . . oo. oo ooo oo oo oo oo•oo · · 1
17 187376 CLUTCH ASSEMBLY- Sprocket ... oo . . . . . . . . oo . . . . . . . .oo . . . . . . . . . . . 00 0000 00000 . . oo . . oo . . . oo . . . oo . . 00000 0000 . . . . . . . oo . . . . oo oo . . oo . . . . 1
18 187415 PAPER GUIDE - os (Long) oooooooooooo oo oo oo oooooooo oo oooo ooooo oo oo oooo oooooooooooooooooooooooooooooo oo oooooo oo ooo oo oooooooooooooo oo . . . . . 1
19 187416 PAPER GUIDE- nos (Long) ooooooooooooo•oooooooooooo . . . . .oo . . . oo.oo . . . . . . . . . . oooo . . oo • • oo . . . oo. oo o o • o o o o o o o o o o · · . . . oooo . . . oo . . o oo oo . . . . 1
20 016327 SCREW· Shoulder, 110-32 x 9/32" .. oo . . . . oo . . . . oo . . . . .oo oooooo oo oooooooooooooooooooooooooooooooooo o oo oo ooooooooooo oo oo oooo oo oo oo . . . . 4
21 016060 SCREW - 10-32 x 3/8" .. oo . . . . oooooooo oo oooooooooooooo oo oo oo o oo oo oo oo oooo oo oooooooooooooooooooooooooooooo oo oooooooo oo ooo oo oo oooo oo oo oooooo 4
22 084473 GUI DE NUT ASSEMBLY ......... oo . . . oo . . oooo . . . oo . . . . . . . .oo . . . oo. oo ooo oo oooooooooooo . . . oo . . . oo.oooo oo oooooooo o oo • • oo . . . . . . . oooo oo oo . . . . 4
23 187581 SCREW- Shoulder, 110-32 x 9/32" 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . . . 1
24 197134 KEY ........... oo . . . . oo . . . . oo . oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . oo . . . . . . . . . . . . oo . . . . oo . . . . . . . oo . . . . oo . . . . . oo . . . . . . . . . . . . oo . . . . oo . . . . 1
25 102569 SETSCREW 00 . . . . . . . .... . ...... . ...... ... .. ... ....... .. ... oo . . . . . .oo . . . . . . . . . . . . . . oo . . . . . oo • • • • • oo . . . . . . . . . . . . . oo • • • oo . . . . . . . . . . . . . oo oo . . . . . . .. . 1
26 187375 HUB- Pile Lift .. oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . o o . oo . . . oo . . . . .. 00 . . . . . . . oo . . . oooo . . . . •ooooooooooooooooooooooo o . . . . oo . . . . . . 00 . . . . . . . . . . . . . . . . 1
27 102602 SPRING- Compression .. oo . . . . . oo . . . . . 0000 . . oo . . . . . 0 0 0 0 0 0 000 0 0 0 . . . . 0 0 0 0 0 . . . . . . . . . . . 0 0 0 0 0 0 0 0 0 0 .. oo 00000 . .... .. oo . . . . . . . . . . . . . . . . . . . . . . . . . . 1
28 102600 RING - Retaining ....... oo . . . . . . . . . . . . . . . oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . oo . . . . . oo . . . . . . oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0 0 . . .. . . . . . 1

STREAM FEEDER
8 --------.
18 -~
I
I
i_
-- -- - ---- -
--1 II
~~-1
-----------

STREAM FEEDER
Index Pa rt
1 254531 STRAP· Mounting, Universal ........... .... ...... ..... ......... ..... ............... ..................... ............................. 2
2 102553 SNAP · Rivet, Plastic .............. ............... ..... .... ..................... ......... ..... .......... .... ............................... 4
3 187735 BRACKET -Wire, os & nos ................................................................................................ ............ 2
4 187413 U-FRAME- Weldment ........... ...................................................................... ............... .................... 1
5 187426 CHAIN ASSEMBLY - Paper Guides ........... ................... .......................................... .. ..................... 2
6 102603 CHAIN VOID- #40; 38 Pitch ................ ................. .......... ............... .............................. .................... 1
7 187450 BRIDGE - Vertical .................................................. .......................................................................... 2
8 187451 BRIDGE - Horizontal ........................ .............. ............ ......... ............... ......... ..... ........ ... .................... 2
9 100891 SCREW - Cap ........................ ..................... .......... .................... ........................................................ 4
10 187457 WASHER ............................................................... ............................................................................ 2
11 102538 NUT- Hex, 1/4 - 20 ............ ............... ............... .. ............................................... ............................... 1
12 187757 LEV ER· Safety ................................................ ............................... ............... ............ ... .................... 1
13 101756 SCREW ................................................................. ............................................................................ 4
14 196834 BOLT - Stripper, Shoulder .. ............. ............... ...... ............... ............................................................ 2
15 187904 FEEDER CONTROL BOX ASSEMBLY ........... ...... ...... .... ..... .................... ................. ... .................... 1
16 102403 SCREW- Mach-C12A, 1/4-20 x 5/8 ...... ......................... ................................................................. 4
17 025205 WASHER ........................... ............... ..... .... ........................................................ ........... .................... 4
18 187912 CABLE - Feeder Main Power ........... .......... ......................... ..... ....................................................... 1
19 254530 MOUNTING STRAP - Universal ...................................................................................................... 2
20 102418 SCREW · Socket 1/4-20 x 1/2 Black .............................................................................................. 4
21 250493 CABLE TIE ........................................ .............. .................................... .............. ........ .. ..................... 2
22 187404 SPACER - Brace, Upper, Machined ................ ................................................................................ 1
23 187924 PCB ASSEMBLY -Accessory Board .............................................................................................. 1
24 187915 CABLE ASSEMBLY- Accessory Board Interface ............... ......... ..... .............................................. 1
25 187932 PC Board - Stream Feeder CPU Final Assembly (With EPROM U20) ............... ......................... 1
26 187932 PC Board - Stream Feeder CPU Assembly (Without EPROM U20) ........................................ 1
27 187934 EPROM - Programmed (U20) .............................................................................. .. ..................... 1
28 400545 LABEL - Shock ................................................ ................................... .... ................ ......................... 1
29 187922 FEEDER - D.C. Power Assembly .... ..... ..... ............................... ................... ............ .... ................... 1
30 102418 SCREW- Socket, Black 1/4-20 x 1/2" ................................. ............................................................ 4
31 001731 LOCKWASHER ................................ ..... .................................................................... .. ..................... 1
32 197930 DECAL - Schematic .............................. ..................................... .... ............... ............... .................... 1
*** Final CPU board assembly part number is on EPROM (U20) as PCBA1 87932.

STREAM FEEDER
4 ----...

STREAM FEEDER
Index Part
1 197429 HOSE PVC -Tubing ....................................................................................................................... 1

2 254531 MOUNTING STRAP - Universal ................................................................................................... 1
3 102553 SNAP - Rivet, Plastic ....................................................................................................................... 1
4 178400 HOSE- 34" ...................................................................................................................................... 1
5 180882 TUBING - 132" .... ............................................................ ........... ................................. ..................... 1
6 TUBING - 18" ..................................................................................... ......... ............. .. ..................... 1
7 TUBING -2" ..................................................... ...... .......................................................................... 1
8 TUBING - 40" ...................................................................... ............... ...................... ....................... 1
9 172713 TUBING · 23" ................................... ..... ................ ..... .................... ................................................. 1
10 TUBING- 18" .................................................................................................................................. 1
11 202708 TIE - Plastic Wrap .............. ......................... ..... ......................... ....................................................... 9
12 178403 TUBING· 30" ...................................................................... ..................................... ....................... 1
13 TUBING - 68" .................................................. ................................................................................ 1
14 TUBING- 24' .................................. ...... .......... .. ... ..... .................... .............................. ................... . 1
15 TUBING - 30" .............................................................................................. .................................... 1

STREAM FEEDER
8 - - - - . . " - . .,, _ ,..-~

'
(/ ~15
9, 9A--..
6 - -"""

STREAM FEEDER
STREAM FEEDER PUMP, COMPRESSOR & BASE ASSEMBLY
Index Part
1 197307 PULLEY ................................. ............... ...... ..... ........................ ..... ........................... ....................... 1
2 172484 V-BELT ..................... ........ ............................................................... ................ .... ........................... 2
3 172485 ISOLATOR- Vibration Mounting ....... ..... ................................... ............................. ... ....................... 4
4 001833 NUT - 1/4-20 ..................................................... ............................... .......................... ....................... 4
5 197560 PULLEY ...................................................... ......................... .................................... .. ..................... 1
6 186435 PUMP- Large Condenser ... ............. ................ ................................... ................ ...... ....................... 1
7 102423 FITTINGNIPPLE-Ciose, 3/4 ............................................................................. .... .......................... 2
8 102421 FITTING · HOSE, 3/4 NPT .. ......................... ....................................... .......... ...... ...... .. ..................... 2
9 186437 FILTER JAR - 3/4 ...... ............................ ............... ............... ................ ............................. ................ 2
9A 187174 FILT ER ELEMENT(Only) ...................................... .............................. .............................. ............... 2
10 150086 LOCKNUT .......................... .............................................. .... ................ ......... ............ .... .... ............... 4
11 102570 SCREW - Hex Flange 5/16-18 x 3/ 4" ................................... ..................................... .. ...... ............... 4
12 187247 MOTOR · 1.5 H.P . ..... ....................................... ...... ............................................ ................ .............. 1
13 102482 FITTING- Elbow, 1/2-14 NPT .......... ..................... ......... .................... ............... .......... ..................... 2
14 102481 PIPE STEEL -1 /2 NPT x 6" lg ......... .......................... .............................. ................. .. ..................... 2
15 102422 FITTING· Hose, 1/2 NPT ................................................. ................ .... ................ ............................. 2
16 186436 JAR- Filter, 1/2" .................. ......................... ..... .................................. ................ ...... .. ..................... 2
17 197435 SILENCER - Exhaust ..................................... ....... .............. ................ ......... .................................... 2
18 150084 NUT -1/4-20 .............................................................................................................. ........ ............... 4
19 187838 PUMP · Small Condenser ................................ ............................................................................... 1
20 001740 LOCK WASHER .............................. ........... .... ... .. ............... ............................. ........ .. ..... ................ 2
21 186431 WIRE- Ground Strap ............. .... ..................... ..... .... ................ .... ................................................... 1
22 187117 BASE ASSEMBLY ... ...................................................................................................................... 1
23 187113 BASE - Blower System ................. ............... ...... .............. ............... .......... ........... ........ ................ 1
24 102337 CARRIAGE BOLT - 5/16-18 ..................... ...................................................... ................... ........... 4
25 187837 PLATE- Stroker Vacuum Pump ........................................................... .......... .............................. 1
26 187116 PLATE- Blower Pump ................................................................... ........... ..... ....... ....................... 1
27 001640 SCREW .............................. .......... ................................................. .... ...... .................... ................ 4
28 102526 SCREW - Hex Flng. Zinc Scr., 1/4-20 x 1/2" .. .. .................. ...... ........................ .............................. 2
29 102487 BOLT- Carriage , 1/4-20 .......... .......................................................... .............................................. 4
30 197297 PULLEY - Two Groove ...................... ............... .. .............................................................................. 1
31 054388 CLUTCH BELT ... ..... ........... .............. ................ .............. ................................... ....... ....... ................ 1

CHAIN DELIVERY

CHAIN DELIVERY

CHAIN DELIVERY
SUPER BLUE
Index Prod. Code

1 5601*** NET KIT- Super Blue, 6 Pack ................................................................................................ 6

2 172773 CYLINDER- Antitracking ..................................................... .................................................. 1
***Use product code number provided above.

CHAIN DELIVERY
5
6
7
13

CHAIN DELIVERY
GRIPPER BAR
Index Part
1 186651 CHAIN DELIVERY GRIPPER ASSEMBLY ....................................... ............................... ............... 1

2 001046 RIETAININGRING .. ......... ...................................................... ................................ .. ..................... 1
3 081764 BEARING ........................... .......... ..... ................................................................... ....................... 4
4 172061 SPRING -Gripper .. .............................................................................. ............... .......................... 2
5 172060 COLLAR- Spring ... .................................................................................................. ..................... 2
6 014164 SCREW - 8-32 x 7/ 16" ................................ .. ...................... ........................................................ 1
7 172742 SHAFT- Gripper .... ....................................................................................................................... 1
8 102378 SETSCREW- #3 .................................... .......................... ........................................................... 2
9 014190 SCREW -10-32 X 1/2" ............................................................................................ ..................... 5
10 014164 SCREW- 8-32 x 7/16" ........................................................................................... ..................... 8
11 080564 PIN ........................ ................................ ....................................................................................... 1
12 172282 LEVER - Gripper .................................................................... ....................................................... 1
12A 102516 CAM FOLLOWER - 10-32 X 5/8" ............................................................................ .................... . 1
128 014248 LOCKNUT ..................................................................................................... ............................... 1
12C 172739 SPACER - C.D. Lever .... ...... ...... ..... .... ......... ..................... .............................. ....... .... ................... 1
13 172744 GRIPPER BAR ASSEMBLY ..................................................... ............................. .................... . 1
14 173357 GRIPPER FINGER PAD ASSEMBLY .......................................................................................... 5
15 014504 RING -Snap ................................................................................... .......... ............ ....................... 2

CHAIN DELIVERY

CHAIN DELIVERY
POWDER SPRAY- WIRING AND BAFFLE ASSEMBLY

Index Part
1 67853198* THERMEL RESET ASSY.......................................................... .............. ........................................ 1

2 CH-0407* CLAMP -1/2 .................................................................................................................................... . 4
3 31060411 * VORTEX SPLITTER - Teflon ...................................................................... .................................... 1
4 33860201* PLUG - Splitter ................................................. ... ...... ........................ ..... ........................................ 1
5 032HN-SPN* HEX NUT .............................................................. .......................................................................... . 4
6 4209905* COLLAR - Tube, Blow Down ............................................. ................................... .. .. ..................... 6
7 67664111* THERMALCUT-OFFASSEMBLY ........................................................... ............................ ............ 2
8 AL-4* CLAMP- Full .......................................................... .... .................................................. ................... . 2
9 632MS12* MACHINE SCREW ............................................................................. ............................................. 4
10 6LWT* WASHER - Lock, #6 ....................................... .. .............................................................................. 5
11 47623410* WASHER - #6 Flat ....................................................................... ...... ......... .................... ................ 4
12 632MS14* SCREW - Machine, #6 .... ............................................................................................... ................ 1
13 CW-0805* CLAMP - Full. ................................................... ..... ........... ..... ........................ .......... ...... ................... 1
14 67526381* POWER CORD - Lamp .................................................. ................................................. ............... . 1
15 14238-FL* TUBING- Flouran 3/16" id x 6 1/2" ................. ................................................................................. 2
16 IRWL-BLUE* LABEL - Wire, Blue ............................................... ..... ..................................................................... 1
17 IRWL-WHITE* LABEL- Wire, White ...................................................................................................................... 1
18 UN5006* CLAMP- Tubing ............................................. ....................................................... .......................... 2
19 34510741 * TUBE - Connect, Brass 6 3/4" ........................................................................................ ............... 2
20 65230571* TUBE ASSEMBLY - Blow Down ....... ..... ........... ... ..... ...................................................................... 1
*Contact Airtech

CHAIN DELIVERY
20
1
19 2
3
4
18 ~
5
13, 14, 15 _ _ _
____J

CHAIN DELIVERY
COVER ASSEMBLY
Index Part
1 032HN-SPN* NUT- #10-32 ..... ............................................................................................................................. 1

2 CH-0407* CLAMP- Half 1/4" ......................................................................... .................................................. 1
3 IRWL-RED* LABEL- Wire, Red ............................................................................. ............................................ 1
4 433241 02* TUBE - Flouran 7" .......................................................................................................................... 1
5 UM5006* CLAMP - (Hidden) ........................................................................................................................... 1
6 26390221 * SHI ELD - Sensor ............................................................................................................................ 1
7 36310211 * BRACKET - Insulated Sensor Extension ....................................................................................... 1
8 26390212* BRACKET - Mounting, Sensor .......................... .......................................... .... ............................... 1
9 440MS34* SCREW - #4-40 x 3/4" ..................................................................................................... ................ 2
10 4LWT* LOCKWASHER - #4 ........................................................................................................................ 2
11 440HN* NUT - #4-40 ....................... .............................................................................................................. 2
12 6778805A* PHOTO SENSOR ASSEMBLY ......................... ............................................... .... ........... ................ 2
13 032MS58* SCREW - #1 0-32 x 5/8" .................................................................................................................. 2
14 10FW* WASHER- Flat, #1 0 .......................................................................... ............................. ................ 2
15 10LWT* LOCKWASHER · #10 ............................................... ..... ................................................................. 2
16 6PHSM14* SCREW - Sheetmetal, #6 ..................................................................................... .......... ................ 2
17 344102A* COOL TUBE ..................... .......................................................................................... ..................... 1
18 21390202* COVER - Outer ................................................................................................................................ 1
19 10LWT* FIBERGLASS- Silicone Coated, #4, 12" ........................................................................................ 1
20 805-1106' STRAP - Ty ............................................................................................................ ........................ . 1
21 67424081 * INDICATOR LIGHT ASSEMBLY ..... ............................................................................. ..... .............. 1
*Contact Airtech

CHAIN DELIVERY

CHAIN DELIVERY
SPRAYER ASSEMBLY
Index Part
1 632MS14* SCREW - Machine, #6 .... ............... ..... .......... ... .............................................................................. 3

2 6LWT* WASHER- Lock, #6 .......... ............................................ ............... ..... .............. ........... .................... 3
3 27490542* SHIELD- Vent ......... 0 • ••••••••• • ••••• •• • •••• ••• ••• • •••••••• • • •••••••••••••• • •••••••••••••••••• • 1
••••••• • •••••• • •• • ••••• • •••• • ••••• • ••• •• ••• • •
4 32930291 * INLET PLATE ASSEMBLY - Sprayer (Left) ................................... ................ ............... .................... 1
5 3291 0381 * SPRAYER - "A"Size, Teflon .................................................. .............. .......... ............ .. ..................... 2
6 032MS12* SCREW Machine, #10 x 1/2" ..................................................................................... .................... 4
0
7 32930301 * INLET PLATE ASSEMBLY Sprayer (Right) .................................................................................. 1

0
8 10LWT* WASHER - .Lock, #1 0 ........................................................................ .......... .................... ............... 4

9 032MS38P* SCREW - Machine, #10 x 318 . ..................................................................................... .................... 4
*Contact Airtech

CHAIN DELIVERY
r---------1
13------... ,...-----2,3
12 - - - - - . . . ,.------ 4
11 ---------

CHAIN DELIVERY
LAMP HOUSING
Index Part
1 FAS170602-24* SPACER - Fastex ................................................. ................ ..... ...................................................... 2

2 623MS14* SCREW - Machine, #6 .................................. ................................................................................. 2
3 6LWT* WASHER - Lock, #6 ......................................... ........ .................................. .................................... 4
4 6SMTAP38P* SCREW - Self Tapping Flat Head , #6 .............. .. ...... .............. ................ ........................................ 2
5 42099098* LAMP HOLDER - Ceramic ................................... ........................................................................... 2
6 6741201A* LAMP - 2000 Watt ....................................... ............... ...... .... ..................................... ....................... 2
7 42211001* FIBERGLASS - Silicone Coated, 9 1/2" .................................................. ........................................ 1
8 480349-0* AMP MALE PLASTIC ....................................................................................................................... 2
9 2779009D* END PLATE ........................................................................................ ............................................. 1
10 623MS12* SCREW- Machine, #6 ..................................... .............................................................................. 1
11 27790611 * BRACKET - Frame ......................................................... .................................................. ............... 2
12 2739021A* REFLECTOR - Lamp ........ ......................... .... ........... ...................................................................... 1
13 36910161* SIDEBAR ........................................................................ .... ..... .......... .......... ................................... 2
*Contact Airtech

CHAIN DELIVERY
6 -----....

CHAIN DELIVERY
FINAL ASSEMBLY
Index Part
1 AL-4* CLAMP ............... .................... .... ..... .......... ......... ........... ..... ...... ......... ......... ...... ............................... 1
2 42411051 * LABEL - Hot .............. ......... ..... ............... ..... .......... .............................. ..... ....................................... . 1
3 8SM12* SCREW - Sheet Metal, #8 x 1/ 2" .......... .......... .. .. .... ...................... .... .......... ................................... . 2
4 480319-10* AMP PLASTIC - Female ................................... ........ .... ...... .............. .............................................. 1
5 8 LWT* WASHER- Lock, #8 ............................ .............................. ......................... ..................... ............... 2
6 832MS38* SCREW - Machine .......... ............................... .. ... ..... .... ..................... ......... ..... ............................... 2
*Contact Airtech

CHAIN DELIVERY
6
7
41
43 8
5
10
4
3
11
2
12
40 13
38, 39
6
1
'----21
' - - - - 22
'-----23
36
' - - - - - - - 24
' - - - - - - 25

CHAIN DELIVERY
POWDER SPRAY ASSEMBLY
Index Part
1 187238 PNUELECTRIC ASSEMBLY .......................... ................................................................................. 1

2 6785052A* SOLENOID ENABLE - Wh ................................................................................. .......................... 1
3 6785151A* INDICATOR LIGHT - Wh ..... ............. ........... ................. ................... ...................... ...................... . 1
4 14T38* TUBING - PVC, 20" ...................... ................................................................. .... .................... ...... 1
5 43443905* TUBING UNION - 3/16" ........ ...................................................... ................................... ............... 2
6 38NB916* TUBING - BRAIDED, 9/16"- 26" ........ .............................. .... ................ ........................................ 1
7 5X442* CLAMP - Tubing ............. .................... ......... ..... ........... ............... ............... ................................... 1
8 6822308A* TUBING- Redux Mifd............................................................................................ .. ..................... 1
9 8-FR089* RESTRICTOR- Flow, (.90) .... ...... ..... ........................................................................................... 1
10 62030* ELBOW - 1/8 NPT ....................................... ..... ............................................................................ 1
11 78304-9000* SOLENOID- DC, 112 Volt Coil ...... ................................... ............................ .. .............................. 1
12 84119103* POWDERMFD.ASSEMBLY ........ ........... ........ ............................................................................ 1
13 I-14T12R* ITUBEASSEMBLY ........ .... ............................... ..... ..... .... ......................... ................................... 1
14 14T38* TUBING- PVC, 7" ........................................................................................................ ................ 1
15 67312051 * TRANAFORMER -IR, 220V .......... .......... ............... ...................................................................... 1
16 832SHN* NUT - Shake Proof, #8 .. ............................................ .......... .... ........... .......... .............................. 4
17 632MS 12* SCREW- Machine, #6 x 1/2" ........................................................................ .... .......................... 4
18 8221402A* HEAT SINK- Triac ....................... ............... .. ................. ...... ..... ..... ................................. ............ 1
19 LCB-2* LAMP CONTROL - PC Board, 220V .................................... .... ............................ ....................... 1
20 41316001 * TRIAC · 600V, 35A ........ ............... ......... ...... .. ........ ..... .... ................ ........................ ...... ............... 2
21 632SHN* NUT - Shake Proof, #6 ................ ........... ............... ............................................. .. .. ..................... 2
22 032HN-SPN * NUT- Shake Proof, #10 .............................................................................................................. 3
23 2446011 A * BRACKET - Mounting, Black Pneuelectric ............ ...... .............................. ................... .............. . 1
24 167838GA * GASKET -Jar .. ............................. ..... ...... ............... ..... .......................................... ....................... 1
25 14LW * WASHER - Split Lock ..... .... .......... ..... ............... ...... .............. .......... ...... ................... ...... ............... 2
26 0420HB58* SCREW - Hex Head, 1/4-20 x 5/8" ........................... ...... .............................. .............. ................ 2
27 417 42006* FUSE HOLDER - Push in, 20A .............................. ...................................................................... 2
28 42423040* LABEL - Jar ..... ............................. ........................................................................ .. ..................... 1
29 41-440* JAR ............................................................................................................................. ................ 1
30 6785554A* POWER BREAKER - Hot, Wh ..... ...... ..................... ..... .................... ............... .............................. 1
31 67554391 * POWER CORD- 220v, 54" .......... ................ ......... ..... ................ .............. .... ............... ................ 1
32 6785555A* POWER BREAKER -Neutral, Wh ................................................................ ............................. . 1
33 252387* CONNECTOR ............... ............... .......... ..... ........... ..... ..... .............................. ....... .. ...... ............... 1
34 251189* CONNECTOR .............................. ...... .................... ..... ..... .............................. ....... .. ...... ............... 1
35 2839007C* COVER - Electrical ...................................................................................................................... 1
36 42415065* LABEL- A.B. Dick Nameplate ...... ......... ..... .. ........ ......... .............................................. .............. . 1
37 6PHSM14* SCREW - Thread Forming Tapping ............. .......................................... ............... ..... ................ 2
38 6785568A* RECEPTACLE - Lamp, Female ........................................................................... .. ..................... 1
39 47420632* NUT - Jam Joy (Not Shown) ...................... ............ ...................................................................... 1
40 42411 054. LABEL - "Check Tubing for Crimps" ...... ......................................... ..................... .... ..... .............. 1
41 14ECT38* TUBING - Conductiive, 21 1/2" ................................................................................ ...... ............... 1
42 42431 052* LABEL- Caution ......................................... ................................................................................ . 1
43 42669012* CLAMP - Tubing ............. .............. ........... .... ...... .... ...... ..... .............................. ............................. . 1
44 42412015* LABEL - Serial .............. .... .......... ..... ............................................................ ..... .... ................. ..... 1
45 42412016* LABEL- Model, A.B. Dick ............................................................................................................ 1
46 42431 052* LABEL- Fuse, 250V, 12A ........................... .. ........ ....................................... ........ .. ..................... 1
47 426690 12* FUSE- 12A, Glass (Sio Blo) ............ .......... .. .... .... ................ ............................. .. .. ..................... 2
48 187239 POWER CORD ASSEMBLY - 1/R Dryer ........................ .............................. .......... .................... 1
*Contact Airtech

CHAIN DELIVERY
~-------- 3, 4, 6, 6
------11
------33
28-------- ~---12
20, 21, 22
'~
~16, 17
18
~---------- 15
29 _____,

CHAIN DELIVERY
INFRARED/ POWDER SPRAY ASSEMBLY- PART 1
Index Pa rt
1 173245 FLAINGE - Powder Spray .. .............................. .............................. .................................................. 1

2 001049 RING - Retaining .............................. ........................................................... .... ............................... 1
3 173251 HOUSING- Powder Spray .............. ...... ......... .......................... .... ................................................... 1
4 150083 NUT - LOCK, 10-32 ......................................... .... .......... ........... ................... ............... .................... 2
5 173252 SHAFT - Powder Spray ................... ..... ..................... ..... ..... ............... ............... ....... ....................... 1
6 014187 SCREW • 8-32 X 3/8" ............................................ .......... .... .......... ................................................... 2
7 172985 HARNESS - Powder Spray ............................. ...... .......................................................................... 1
8 014288 SCREW - 10-32 X 5/8" ..................... ........................................................... ............. .. ..................... 2
9 001812 NUT - 10-32 ............................ ............... ......... ..... ...... ..... ................................................................. 2
10 102355 SCREW- Black Oxide, 10-32 x 9/16"... ............................. .............................................. ................ 1
11 186764 PANEL - Inside ................ ............... ..... ..... ...... .. ........ .... .............................. ............... .... ................ . 1
12 173259 COMPRESSORASSEMBLY ..... .... ..... .......................... ..... .......... ................... ..... ...... ..... ................ 1
13 102303 SCREW - Hex Flange, 1/4-20 x 3/4" .............. ...... .............................................. .............. ................ 3
14 191797 WASHER . .......... ...... ........ ............... ..... .......... ...... ..... ........... ........................ ................... ................ 8
15 172634 BRACKET -Compressor ................ ..... .......... .. .... .... .......... ........................ ........... .. ....... ................ 1
16 102486 SCREW- Hex Flange, 3/8-16 x 3/4" .............. .................................... ................ .............. ................ 2
17 150084 NUT · 3/8-24 ...................... ............... ......................... ...... ........................................... ...... .............. . 6
18 102157 SCREW - 10-32 x 3/8" ...................................... ...................... .................... ............. .. ..................... 2
19 197420 TUBE- Powder Spray ................................................................................................. .................... 1
20 001731 WASHER · Lock, .250 i.d. x 485 o.d......... ...................................................................... ................ 2
21 001640 SCREW - 1/4-20 x 5/8" .................................. ...... .......... .......................................... .. ...... ............... 2
22 173250 SPRAY HEAD- Manifold .......................... ................ .... .................................................................. 1
23 111054 SCREW- 10-32 x 1/2" .................................................................................... ................ ................ 2
24 173249 BRACKET - Manifold ....... .......... ...... ..... .... ...... ........... .......... ............................. ........ .. ...... .............. . 1
25 001812 NUT - 10-32 ............................ ............... ..... .... ................................................................. ................ 1
26 102572 SCREW- Hex Flange, 1/4-20 x 1" .................................................................... .... .......................... 1
27 254472 CLAMP- Cable ... ............................................................................... .................... ................... ...... 1
28 180472 KNOB ................................ .... ............................... .............................. ..... ..... ..... .............................. 1
29 101537 FITTING ............. ....... ......... .... ............... ........... .... ..... ................................... ............ .. ..................... 1
30 173256 BUSHING- Flexible Shaft .......................... ............... ........................................ .............................. 1
31 250077 STRAP - Stay .................................... ............................... ................................................................ 2
32 174149 SHAFT - Flexible ....... ............................ ........... .... ..... ................ ................... ............ .. ..................... 1
33 174374 SHI ELD- Compressor 1/R P.S........................................................................................................ 1
34 CLAMP ................. ............................................ ............................................. ............ ....................... 3
35 102124 CAPSCREW - Button Head .... ............................. .................... ................ ................... ...... ............... 2
36 001812 NUT- Hex ........... ...... ................................................. ...................................................................... 3
*Contact Airtech

CHAIN DELIVERY
1 --------,.
14, 15- - '

CHAIN DELIVERY
INFRARED/ POWDER SPRAY ASSEMBLY- PART 2
Index Part
1 250077 STRAP- Stay 0 0 0 0 0 000 . . o . o . . 0 00 . . . . . . o . . . . 0 . . . . . . . . . . o . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . o . . . . . . . . . . . . . . . . . . . . . . . 0 . . . . o . . . . . . o 0 . . . . . . . . . . . . . o . . . . 0 . . 0 1

2 250356 CLAMP - Cable .. 0 0 ....................... 0 .... 0 .................. o .. .. o ........ o .......... . . . . . o . . . . . . . . 0 . . . . o . . . . . . 0 . . .o . . . .o . . . . . . . . . . 0 . . . . 1
3 6778805A* PHOTO SENSOR ASSEMBLY- Jam .............. .... o . . . . o . . . . . . . . . . 0 . . . . 0 . . o . . . . . o . . . . 0 . . . . . . . . . . . . . .o . . . . . . . . o . . . . . . . . . . . . o . .o 1
4 100204 SCREW - 4-40 X 3/4" ........ 0000 0 00 000 . . . . . . 0 000 . . . . 00000 oo OoOOO 00000 00000 . . . . 00000 00000 00000 0 00000 OOooo . . . . 00000 000 000 00000 0000000 . . 000 0 . . 2
5 100115 NUT - 4·40 .... o . . . . o o . . . . . . . o . . . . . . o . . . . . . . . o . . . . . . . . o . . . . . . . . . . . ... . . . . . . o . . . . o . . . . . . . . . . o . . o . . . . . o . . . . . . . . . . . . . . o . . . . . . oo o . . . . o . . . . . . . . . . . . . . . . 2
6 26390212* BRACKET - Mounting, Sensor .. o . . . . o . . . . . . . . . . o . . . . . ... . . . . . . o . . . . o . . . . . . . . o . . . . o . . . . . . . . . . . . . . . o . . . . . . . . o . . o 00 000000 . . . . . . . . . . . . 0 . . 1
7 111052 SCREW· 10-32 x 3/8" ............ oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . o . . . . . . . . . . . . . . . . . . . oo . . . . . . . . . . . . . . 00 . . . . . . . . . . . . . . 2
8 173093 PLATE · Photosensor Support ...... o . . . . o . . . . . . . . . . . . . . o . . . . . . . . . . . . . . o . . . . o . . . . . . . . . . . . . o . . . . . . . . . . 0 . . . . . . 0 00 0000 0 00 . . . . . . . . . . . . 0 0 1
9 186760 BRACKET ASSEMBLY - Powder Spray, os ...... 0. . . . . . . . . . . . . . . . . . . . . . . . . . 0 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . .. . 1
10 111053 SCREW- 10-32 x 3/8" ...................................... ...................... .... 0 ........... .. ...... ...... ........ .. ................ 3
11 172717 SPRING · Hold Down .. o . . . . o . . . . o . . . . . . . . o . . . . o . . . . . . 0000 . ... . . . . . . o . . . . o . . . . . . . . . . o . . o . . . . . o . . . . o . . . . o . . . . . . . . . . . . 00 . . . . o . . . . . . . . o . . . . o . . 1
12 173250 SPRAY HEAD- Manifold .. .. ooo . . . . o . . . . o . . . . oo . . o oo ooo oooooo . . . . o . . . . . . . . o oo . . . . . . . . . . . . . . . . . . . . . o ooo ooo oo ooo . . . oo . . . . o . . . . . . . . . . . . o . . o 1
13 101051 NUT - 10-32 .. o .... o .... o . . . . . . . . . o . . . . o . . . . . . . . o . . o ooo . . . . o . . . . . ... . . . . . . o . . . . o . . . . . . . . . . o . . o . . . . . o . . . . o . . . . . . . . . . o . . . . . . oo . . . . o . . . . . . . . . . . . o . . o 2
14 186759 BRACKET ASSEMBLY- Powder Spray, nos ................................................................................. 1
15 111053 SCREW. 10-32 X 3/8" ooooooooooooooooooooo oo oooooooooooo ooo ooooooooooooo oo oo oo ooooooooooooooooooooooooooooooooooooooooooooooooooooooooooo 3
16 36310211* BRACKET - Insulated Sensor Extension ........ 0 0. . . . . . . . . . . . . . . . . . . . . . . . . . 0 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
17 4LWT* LOCKWASHER - #4 ..... o . . . . . . o . . o . . . . . . . . o . . . . . . . . . . o . . . . . .. . o . . . . o . . . . . . . . . . o . . . . . . . . . . . . . o . . . . o . . . . . . . . . . o . . . . . . o o . . . . . . . . . .. . . . o . . . . . . 2
' Contact Airtech

CHAIN DELIVERY
6 : - - -10
~11 12
13
12

CHAIN DELIVERY
INFRARED POWDER SPRAY ASSEMBLY- PART 3
Index Part
1 253932 KNOB - Black .... ................... .......... ..... .......... ..... ................ ..................................... ....................... 3
2 38PANEL* NUT - Jam ........ .............................. .................... ............. ............... ........... .... ........... .................... 2
3 032HN-SPN* NUT - Shake Proof #10 .................. ..... ........ ........................... ....................................................... 2
4 174368 BRACKET - Mounting .... ................. .... .............. ......................................... ................................... 1
5 WASHER - Lock ............................ ..... ............ ........ ........................................ ....... ....................... 1
6 174366 POT ASSEMBLY - Intensity ............ ............................... .............. ................................................... 1
7 43453904* UNION - Reduction ................................................. ..................................................................... . 1
8 IRWL-BLUE* LABEL - Wire ................ ................... .... ...... ............... ......................................... ...... ......... .............. 1
9 8-FR66* FLOW RESTRICTOR ............ ............... ................ ..... ................ ......... ............................................. 1
10 CW-0805* CLAMP - Tubing .............. .................................. ............................................................................ 1
11 832HN-NYL* NUT - Hex, #8 ... .............. ............... ..... .... ................. ....................................... ........ .. ...... .............. . 1
12 14T38* TUBING - 21 .5 Inches ..... ............................ ... .................. ......................... ...... .... .. ....... ................ 2
13 6831503* VALVEASSEMBLY .. ..................................... ....................................................... ............... ............ 1
14 6955008* SUPPORT ASSEMBLY - Shaft ..... ..... ............ .. ............ ................................................................ .. 1
15 2979021 * MOUNTING PLATE- Valve ....................... .................................. ................ .... ............... ............... . 1
16 174367 CONTROL PANEL .............................. ............. ........... ............... ...... .............................. .... ............ 1
17 187184 LABEL - P.S./ I.R . .......... .... ................... ........... ........ ...... .................... ................ ...... .. ..................... 1
' Contact Airtech

CHAIN DELIVERY
1
0 0

CHAIN DELIVERY
POWDER SPRAY- COMPRESSOR ASSEMBLY
Index Part*
1 173259 COMPRESSORASSEMBLY ......... ..... ........... ..... ...... ................... .............. ..................................... 1
2 43466315* ADAPTOR ....................................... ................................................... ............................ ................. 1
3 GSTFILTER* FILTEA - Plastic lntalke .................................. .......................................................... ....................... 1
4 112C* VALVE· Pressure Relief .. .................... ........................................................ ................................... 1
*Contact Airtech

CHAIN DELIVERY
Section A-A
3,4,5,
6

CHAIN DELIVERY
TABLE DESCENT
Index Part
1 187332 CHAIN KIT- (includes os & nos) ..... ............................................................ .................................... 1

2 196768 SPRING - Stud ............. .................... .......................................................................... ..... ................ 1
3 102219 SCREW- Dowel, 3-8-24 ................. ..... ................................................. ........................................... 4
4 001771 WASHER- .375 i.d. x .875 o.d. ...... ...... .... .................................................. .................................... 4
5 001763 WASHER - Lock, .385 i.d. x .675 o.d ........... .................................... .... .......................................... 4
6 001845 NUT- 3/8-24 ............................................................................... ....... ..... .... ..................................... 4
7 194835 "S" HOOK ........ ...... .................... ......................... .... ................... ....... ..... .... ..... ................................ 2
8 016405 BAR - Tie ............... ......................................... .... ..... .... .............. ....... ..... .... ................ ..................... 1
9 111073 SCREW- 1/4-28 x 5/8" ................................................................ ................................................... 2
10 172304 CARRIER GUIDE ASSEMBLY- nos ............................................................................................... 1
11 172303 CARRIER GUIDE ASSEMBLY - os ..................... .................... ... .. ............... .................................... 1
12 101943 NUT -Acorn, 1/4-20 ......................... ............... .... ......... .............. .. ........................ ...... ..... ............... . 4
13 172649 STUD- Eccentric ................................................ ..... ........................ .......... .................................... . 2
14 100871 NUT - 1/4-20 ................................................................. .......... .... .. ..... ..... .... ................ .... ................. 2
15 196390 CAR - Roller ..................... ..... ...... .... ..... ......... ...... ..... .... .............. .. ..... ..... .... ..................... ................ 4
16 001060 RING- Retaining ............................................................................................................................. 4
17 172287 CARRIER AND RAIL ASSEMBLY- os .................... .................. .. .......... ........................ ................. 1
18 172286 CARRIER AND RAIL ASSEMBLY - nos ............. .......... ...... .......... .... .......... ...... .......... .................... 1
19 001060 RING- Retaining ............ ................. ..... .......... ..... ..... .... .............. .. ..... ......... ..... ................................ 2
20 016399 W EIGHT ASSEMBLY .......................... ................... ......................... ......... ...... ................................ 2
21 100871 NUT - 1/4-20 .. ............................................. ..... .......... ..... .... ..................... ..... ................................... 4
22 016449 TINSELASSEMBLY ....... ............ .... ..... ............... ...... .... ..... ........ ............ .... ..................... ............... . 1
23 050621 SPRING ................. ......................... .......... .... ......................... .... ............ ......................................... 2
24 016389 DOLLY ASSEMBLY .......................... ......... ..... .......... .... .......... ... ... .............. ................ .................... 1
25 197185 SCREW- 5/16-24 x 3/4" ................................................ .... ..................... ... .................................... 16
26 400900 TOPDOLLY ...... ............... .......... ..... ........... .... ..... .......... ..... .... .... ............ ..... .................................... 1
27 400901 BASE DOLLY .. .. .. .. .. .. ... .. . .. ... .. .. ..... .... . ... .. . .. .. . . ... .. .. . ... .. .. .... .. .. . ... .. .. .. .. .. ... .. . .. ... .. ... .. .. .. .. . .. .. .... ..... ... .. 1
28 081516 CASTER- Swivel .... .......... ...... ..... .... .......... ..... ................ .... .............................. ...... ......... ..... ........... 2
29 014809 NUT -5/16-24 .... .............. ............... ........... .... .......... ...... ..... ........ ........... .......... ........... ..... ............... 16
30 081515 CASTER- Rigid ........................................ ..... ......... ..... ........... ..... .... .......... .............. ....................... 2
31 064673 SPRING ....................... .............................. ..... .............. .............. .................... .......... ...................... 1

CHAIN DELIVERY
4 30,31
0
17
()
18 0 0
19
•
9 0 0
28 0
27 0
23 0 0

CHAIN DELIVERY
PAPER SUPPORT TAB AND FRONT GUARD
Index Pa rt
1 102356 SCREW · Black Oxide, 10-32 x 1/2" ........... ... ... .. ..... ...... ..... ..................................... ....................... 4
2 150083 LOCKNUT ........................ .............. ...... ............................. .............................. ............................... 6
3 187386 BRACKET- C. D.Guard n.o.s. .......... ...... ......... .......................................................... ........... ............ 4
4 187384 GUARD- C. D. Fixed ........... ........................ ..... .......... ..... ................ .............. ............... .................... 1
5 102334 SCREW -Black Oxide, 10-32 x 9/16" ......................................................................... ..................... 4
6 102357 SCREW- Black Oxide, 10-32 x 1/4" ............................................................................................... 1
7 186614 BUSHING -SPecial Flange ........................................................................................................... 4
8 101938 RING - Bowed ................................................................................................... .............................. 1
9 187357 SHAFT - Jogger, Front ..................... ................................................................................................ 1
10 102381 SCREW- Black Oxide, 10-32 x 5/16" ................................................................ .............. ................ 1
11 102318 SCREW - Black, 10-32 x 3/8, #36 ................... .................................................. ....... .. ..................... 2
12 001060 RING • Retaining .............................................................................................. ........ .. ...... ............... 2
13 001095 RING - Retaining .............. ..... .................................................................. ......................... .............. . 1
14 187390 PIN - Interrupt Finger ...................................................................................................................... 1
15 014507 RING • Retaining .............................. .............. ........... ................... ............................ .. ..................... 2
16 187095 LINK- Interrupt .................................................................................. ............................... ............... 1
17 187397 PLATE - Interrupt Finger .................. ............................................................................................... . 1
18 187398 STUD ................................................ ........................................................................ .. .... ................. 1
19 187395 LEVER ASSEMBLY- Interrupt ........................ .................................................................. ............... 1
20 187389 COVER • Paper Interrupt Finger ..................................................................................... ............... 1
21 100858 SCREW ............................................ ................................................................ ....... .. ..................... 2
22 187097 LEVERASSEMBLY .............................. .......................................................................................... 1
23 102441 PIN- Dowel, Sti./Grnd., 1.26/ 1.24 .................................................................................................... 2
24 187075 LEVER - C.D. Gate Stop .................................................................................................................. 1
25 014158 SCREW ................................................. .......... .......................... .............. ................. ....................... 1
26 186963 BUMPER ................................................................................................ ......................... ............... 1
27 187388 FRONT STOP - Fixed ...................................... ................................... ................ .... .. ....................... 1
28 187374 FINGER - Interrupt ................................. ............... ................ ..... ...................................................... 1
29 187340 ADJ. STRIPPER FINGER ASSEMBLY ........................................................ ................................... . 1
30 186590 FRA ME - C.D, o.s. ................... ......................................................................................................... 2
31 186591 FRAME - C.D, n.o.s............................................................................................. ...... ....................... 1
32 187082 FINGER - Jogger .................................. ...................................................... ...... .............................. 4
33 186794 PLATE - Jogger Finger ................................................................................................... ................ 4
34 186796 FASTEN STRIP- Loop ............................................................................................... ..................... 4
35 186797 FASTEN STRIP - Hook .......... ................ ................................................. ........................ ................ 4
36 102350 SCREW - Black, 10-32 x 3/4", #36 ................................................................................. ................ 4
37 012379 NUT ................................................. ..... ........... ...................................................... .. .. ..................... 1
38 001706 LOCKWASHER ................ ............... ..... ...................................................................... ..................... 1
39 102318 SCREW - Black, 10-32 x 3/8" ,#36 ................................................................................. ............... . 2

CHAIN DELIVERY
-------------- 6
12
/,--------- 7
, I)
1---'("'
---9
-----11
"-----4

CHAIN DELIVERY
TRACK ASSEMBLY
Index Part
1 186220 TRACK- Top .... ... ........................................ ..................................................................................... 2

2 102014 SCREW- Socket Head, 10-32 x 1-1/ 2" .............. .. ......................... ................................................. 15
3 005607 WASHER - Flat ............................................................................................................................... 16
4 186536 SPACER ................................ ......................................................................................................... 16
5 101193 SCREW - Cap, 8-32 x 5/8" ............... ............... ................ ..... ..... ................................ .. ..................... 2
6 196988 BUMPER .................. ............................................ .......... .... .......... ............................... .................... 2
7 150081 NUT- Lock, 8-32 ....... ............................. ............... ..... ........... ........................................................... 2
8 173248 BRACKET ASSEMBLY ...... .................. ...... .... .. .................. ..... .... ................ ..... .............................. 1
9 186223 STRIP - Wear, Bottom ........................................... .... ................ ...................................................... 2
10 102175 SCREW - Button Head, 10-32 ............................... ................ ........................................................... 1
11 186222 TRACK - Bottom ........................................................ ................................... .... ............................... 2
12 186221 STRIP- Wear, Top .......................................... ................ ...... ......... ............... ................................... 2

CHAIN DELIVERY
. - - - - 6,7,8
9
10
0
0
0
0
0
9
10
1 5 - - --' 11,12,13

CHAIN DELIVERY
CHAIN DELIVERY (NOS FRAME)- PART 1
Index Part
1 150083 NUT - Lock, 10-32 1

oo· · · oo· · · · · • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • •
2 074399 BEARING ........... .............. .................................... ........................................................................... 1

3 186939 STRUT ASSEMBLY ........................................................................................................................ 1
4 172811 SCREW - Shoulder ............... ............... .................... ......................... .......... ......... .......................... 1
5 191797 WASHER - .265 i.d. x .625 o.d ...................................... .......... .................... .................................... 1
6 186757 BRACKET- Mounting Light, C.D........................... ......... ........... .............. ........................................ 1
7 102334 SCREW- Hex Washer Head, 10-32 x 5/8" ........................................................... .. ....................... 2
8 150083 NUT - Lock, 10-32 ............................ .... ......... ................ ......................... ..... .... 2 00 oo• oo• . . 00 oo• 00 00000000 00 00 00
9 101938 RING - Bowed 4

ooooooooo o ooooooOOOooooooo oo o o o o • o o · oo• oo oo oo oo oo . .oo . oooo . oo oo. oo oo oooooooo oooooooooooooo oo. oo oo. o o o o o o . o o o o o o . o o o o o o o o . o o o o · · ·
10 186614 BUSHING 000000000000 • • 00 . 4

000 00 000000000000000000000000000000 00 00.0000000000000000000000 0000 00000 000000 0 00 0000000 0000·00 - 0000 00 0000 0000 0 0000 000.
11 172310 BALLASTTRANSFORMERASSEMBLY 1
oo. oo . . . oo .oooooo oooo • oo• oo •oo ooooooo oooooooooooo ooooooo oooooooo• • ooooooooooooooo oo o oooo •
12 102334 SCREW -Black Oxide, 10-32 x 9/16" 2

00 00 0000 oo oooooo 00000000 0000000000 00 00 oooooooooooo oo oooooo oo oo oooooooo o oo oo oooo oooooo oo oooooo•
13 150083 NUT- 10-32 oooooooooooo • • 2

oooo oo ooooooooooooooooooo o oo•oooo• oooo • . .oooooo •oooooooo oo oooooo• oo oooooo ooo ooooooooooo oo o oooooo oooooo o oo oooo oo oooo • oo ·
14 001706 WASHER - Ext. Teeth, #10 4

oo ooooooo oo oooo oo oo oo oo oooo • oo •oo oo oooo oo ooo oo oo oooo o oooooooooooooo oooooo ooooooooooo oo oo oo oooooooo oo oo oo.oooo
15 001220 SCREW ...... oooo·········• 1

o o • o o • • o o o o · · · · · o o o o • • • • • • oo . . . . . oo . . . . . .. oo • • o o . o o o o · · · · . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . o o . o o • •
16 186593 GUARD - Chain 1

oooo o oo o oooooooo o ooooooo ooo oo oo oooo •oooooo . . . . . . oo oooooooooo• oo oo•oooooooo ooo oo oooo ooooooo•oooo •oooo o o . 000000 0 0000 0 0000 00 0000.
17 192209 SPACER 2
OO OOoo O OO OOOooOOOO O ooOOOOOOOOOOOOOOO O OOOO OO OO OOOOOO OOOO O OO . .OO O OOOO O OO OOOO OOooOOO OO OOOOOOOOOOOOO OO OO OOO oooooooo • o o • • • oooo oo oo oooooooo oo oo •
18 102014 SCREW - Socket Head, 10-32 x 1-1/2" 2

oooooooo oooo oo oooo oo oooooooooooooooooo oo ooooooooooooooooooooooooooo oo oooooooooooooooooooo.
19 005607 WASHER- Flat oo· oo· · ·· 2

oo•ooooooooooooooooooo • oooooooooooooo o oooooooooooooooooooooooooooooooooo ooo oooooooooooo •oo ooooooooooo o oooo • oo• oooo • oo ·

CHAIN DELIVERY
5
4 ~- 10 , 11 , 12 ,
/ / /____ ,.u;u.,m-1-""'-, 13' 14
1/ /
I I
/' /'
!
1 I
/
I I
I
I I
l
I I
I
1 I
I I
: /
! / ; ; : 18,19,20,21
1
\
I
,
Fl
(n)
r, --o--- ---- --------or--------------- f ------ -t:;:- -------- - - - - -
~o
t1'
\ : :etl •
~
1111
I " 1I ::: : o
~
I
..-.-L.-,
\
I ~:::
1° ( I ~o--o-·.llll
~ CQ)'~ _- ;~ ~~0~~ 0 @
~ @' {(li'. I
I o \l
' 'l ;O:I
II o ~ ' ':
~
I r-'~ ~
@ ~'
-:l!
!i~~----·-:! _:__(~
~
i \...Q,i 0 0
0
l ____________________ _______________ 0
_______________ __ _
22,23

CHAIN DELIVERY
CHAIN DELIVERY (NOS FRAME)- PART 2
Index Part
1 081527 TENSION - Chain ............................. ..... OO oO oo .... . OOoO .............. ........... .. oo .......... .. oo .. ...... ....... .. oo ............ 1
2 150083 NUT - Lock, 1 0-32 000.00 00 00 00 oo oo. 00000 00 0000 0000 0000 000 00 000 00 00 00 00 oo oo. 0000 00 00000000 000000 00 00000000 00 00 00 0000 00 00 00 000 00 00000000 000 000 2
3 001260 SCREW. 10-32 X 1-1/4" OOOO OO OOOOOOO OO OOO OOO OO OO oOOOOoO oO OOOO oO OOOOOOOoOoOOOOOOO oO OOOOOoOOO OoO OO OOOOoOoOOO OOO oO OOO OO oOoO OoOOOoOOO OOOOoO OO 2
4 081528 SCREW - Special Adjustment ... oo ... .. oo . .... oo ... . oo .oo .. 00 oo ............ oo. oo. ooooo . ..... 0000 .. oo. oo ...... ... 00 00 ........ oo ...... 1
5 001840 NUT - 5/16-18 ........ oo. oo ...... oo ... oo .... oo ..... OOOOo0 00 00 00oOOOOOOoOOOOOOOoOOOOOoOoOOOOOOoOOOOOOoOOOOoOO ... oo ....... oo .. oo· oo .. oo ........ oo 1
6 023044 SWITCH ACTUATOR ASSEMBLY . oo ..... oo .. 00000 000 ... oo. 00000 oo ..... oo ........ 000 .. oo. 00000 oOOOOO 00 000 ... oo .. oo ..... 0000000 ..... 1
7 021203 WASHER- .254 i.d. x .500 o.d ... OOOOOOoOOOOOoOOOOOoOoOOOoOOOOOOOOOOOOOOOOOoOOOOOOOOoOOOOOoO OOOOoOOOOOOO .... 00 . ...... ................. 2
8 006675 WASHER · .253 i.d. x .500 o.d ........... 00 ............... oo .. 00 ...... 00 ...... oo ........ oo .. oo ......... ........ .... oo oooooooo......... 2
9 001060 RING - Retaining oooo ........ OOOOoOOOOoOOoOOOOOoOOOOoOoOoOOOOOO oo ....... OOOOOOOOOOOoOOO ......... oo ...... oo .... oo . ..... oooo ... oo ........... oo. 2
10 087756 PLATE ....................... ...................................................................................... ................................ 1
11 102380 SCREW · Black Oxide, 10-32 x 3 /8 " OOOOoO ........ 00000000 .. OOOOoO OOOOOOoOOOOOOO 00000 000000 0000 000000 00 00 0000 00 00 00 OO OOOO oOoOOO 00 00 2
12 006675 CHA NNEL · Washer oo oooo oooooooooooo oo oooooooooooooo oo •oo•••ooooooooooooooo ............. oo. oooooooo ... oo . .. oo. oo •oo oo ooo oo oo oooooooooooo 2
13 022621 WASHER - . 197 i.d. x .500 o.d. OOOOOOoOoOOO OO OOoOoOOOoOoOOOOOoOOOoOoOoOOOOOOOoOOOoOOOOOOOOoOOO oO OOoOOOOO OOoO OO OoOOO OO OO OOOO ........... 2
14 172893 CHAIN DELIVERY FULL SWITCH ASSEMBLY OOOOOOOOOOOOoOOOOOOOOOoOOOOOoO OOOO OOoOOOOOOOoo OO oO OOoOO OO oOOO OO OOoOOOoOoO OO OO O1
15 196330 SHIELD · Terminal OO OOO OOO oOOOOOOOOoOOOO OO OO OOO OOOOoOOOO ooOO OOOOo ooooooo oooooooo ..... oooo . .. oo . .. oo .oooo ... oo .... oo .... oo oooo oo oooo ...... oo. 1
16 102342 SCREW. 2-56 X 5 / 16" oOOO OOoOoOoOOOOOoOOO oO oOOOOOOOOOOOoOOO OO OOOOOOOOOOoOOOOOOOOOOOOO oOoOOOOO oOOOOOOOOOoOOOOO OO OOOOOoO OO OO oOOO OOOOoOoOOOO 2
17 100137 NUT- Hex, 2-56.0000. 000000 00 000 00 00 00000 00 00 000 0000 .. oo oo ... oo .... oo ... 00000 000000 0000 00 00 0OOoO 000000 00000 00 000 0000 000 00 0000 0OOoO OOOO 000000 00 2
18 186562 GUARD - Chain ooooooo ooo oo oo OO Ooooooooooo oo oo oo ooooooooooo oo ooooooooooooooooooooooooOOOOOOO OOO OO OOoOOOOOOO ... oo oo oooo o... 00000000000000000000 1
19 192209 SPACER oo ooooo oo ooooooooo ooooo oo oooooooooooooooooooooooooooooo oo oo•oooooooooooooooooooooooooooooooooooooooooo•oooooooo·oo·•·oooo oo oo oooo oooo oo oo o 2
20 065833 SCREW · Socket Head, 10·32 x 1·1/4" 00000000 .. 000000000000000000000000000000000000000000000000 00 00 00 00000000 00 0000000000000000 2
21 005607 WASHER - Flat oooooo ... oo.oo ooooooooooooo oooo ooo ooooooOoo OO oo••oooooooooooooooooooo oo oooooooo ooo oooOoooooooooo ooo ooooo oo ooo oo oooooooo oooooooo 2
22 102332 SCREW · Black Oxide, 10-32 x 3/8" OOoOOO .. oo. oo .. oo 00 oo ...... oo ...... 00 00 OOoOOOOOoO 0000 00 .. 00 ...... oo ..... 00 oo ... oo ........ oo 0000 1
23 081107 CLIP - Spring 00 .. 00 ... . .... 00 00 00.00 000 00 00 OOoO. 00 000 00 00 00 00 00 . ..... 00 00. OOoO. 00 .. oo 00 00 ...... 00 00 00 00. OOoO. 00 .. oo 0000 00 00 00 00. 00 00 00 00 00 00.00 . 1

CHAIN DELIVERY
3,4,5,6
2
7
'------- 8
,--·-,
@·
·-;';--~ ·~-e~ 1~
r
' fl I I e~
;~~ , ,
I
/
I ~- 15, 16
!
:
''
'
''
\
o•
':.
0
\
0
I
'!J--'
' --..' 0
o jo
\
r·~--. -, -~-J
0
0 '
: I ~ ''
/
t • 0
@ A A
0
@
0 0
0
11 ,12,13,14
'---- 17,18,19

CHAIN DELIVERY
CHAIN DELIVERY (OS FRAME)- PART 1
Index Part
1 102334 SCREW .............................. .............. .......... ................................. ... .............. .......... ........................ 2
2 016456 JOGGERARM .............. ............... ...... ......................... ......... ........................................ ................... 1
3 187085 PIVOT SUPPORT ASSEMBLY ...... ..... ......................................................................................... 1
4 001095 RING - Retaining ..................................... ................................... .............. .................................. 1
5 001060 RING - Retaining ............ ......... ..................... ..... .... ..... ..... ............ ................................................ 2
6 016470 JOG ROLL ASSEMBLY .................. ........................ ..... ............... ................................................. 1
7 196453 SHAFT ............................................................... .......... ..... ............................................................ 1
8 016471 ARM - Lever ...... .......... .............. ..................... .... ..... ..... ...... .......... ................................................ 1
9 186614 BUSHING ....... .............. ............... ..... .... ................ ..... ..... .... ...... ... ................................................... 3
10 101938 RING - Bowed ..... ................................................. ..... ..... ........... ..................................................... 3
11 186593 GUARD - Chain ............. ................ ..... .............. ..... ..... .... ............. ... ................................................ 1
12 192209 SPACER ........................................................... .............. ................ ................................................ 2
13 065833 SCREW - Socket Head, 10-32 x 1-1/4" ................. ..... .... ................................................................ 2
14 005607 WASHER- Flat .............. ............... .... ................ ..... ..... .... ................ .............. ............... ................... 2
15 186441 HUBASSEMBLY .............................. .... ................ .......... ........... .... ............... ..... ............................. 1
16 197038 NUT .................... ................................................... .... ................ .............. ....................................... 1
17 186757 BRACKET - Mounting Light .......... ..... ............... ..... .... ................................... .................................. 1
18 102334 SCREW - 10-32 X 9/16" ................. ........................ ...... .... ............... ........................ ........................ 2
19 150083 NUl - 10-32 ...... ................................................ ..... .... ................ .. ............ ....................................... 2

CHAIN DELIVERY
Section A-A
1,2,3
----- 4,5
0 0 0
~6,7 0
.-----------------------------------------. - - - - - - '
'
'

CHAIN DELIVERY
CHAIN DELIVERY (OS FRAME)- PART 2
Index Part
1 186562 CHAIN · Guard ... .............. .............. ................ .. ........ ......... ...... .......... .... ................ ......................... 1
2 192209 SPACER ............ ............................... ..... .............. ........................ ................ .... ............................... 2
3 065833 SCREW· Socket Head, 10-32 x 1-1/4" .............................................. .............. .............................. 2
4 186623 SPACER - Cam .. ............................................. .............. ........... ..... .......................... ... .................... 1
5 191786 SCREW · Special ................................................................ ............... ............... ....... .. ..................... 1
6 081107 CLIP- Spring ..................... .............. ................ ............................... .... ................ .... .. .. ..................... 1
7 111052 SCREW· 10-32 x 3/8" .............................................. ............................................ .......... ................ 1
8 186599 CAM - Crank Assembly .................................. .................... ......................... ............ .. ..................... 1
9 001956 PIN - Taper ....................................... ..... ............................. ..... ....................................................... 1
10 111052 SCREW- 10-32 x 3/8" .................................................................................................... ................ 2
11 016441 BEARING ......................... ................ .... ..... ...................... .... .......... ...... .............. ............... ................ 1
12 001076 RING - Retaining ............................................ ............... ..... ............... .............. ........ .. ...... ............... 1
13 016398 LEVER -Tension, RH ........ ............................ .................................................. .............................. 1
14 081527 TENSION · Chain .......... .................................. ............................... .... ................ ...... ... .... ................ 1
15 150083 NUT - Lock, 10-32 ............................ .... ..................... ..... .... .......... ...... ...................... .. ..................... 2
16 001260 SCREW. 10-32 X 1-1/4" ................................ .. .............................. .................................................. 2
17 081528 SCREW • Adjustment ........ ............................................ ...... ........ ............................ .. ..................... 1
18 001840 NUT · 5/16·18 ...................................................................... .............................. .... ......................... 1

CHAIN DELIVERY
5
6 8
7 NOS
\__ 10,11 ,12,1 3

14
r 9,10,11 ,12
OS
1,2
0
0
0
0
0
0 0
0
:@
0
0 00
3 0
0 @
0 0 0
0
0 0
0 64 60 0
0 0
0 0 0
0 0 0
0 0 0
0 0
19,20,21 ,22,23

CHAIN DELIVERY
CHAIN DELIVERY JOGGER ASSEMBLY
Index Part
1 186752 BAR - Tie ............ ...... ........ ..... ........... .... ........................................................................................... 1
2 186770 SCREW- Dowel ................................................. ........ ..................................................................... 2
3 016452 SHAFT ............................................................ ......... ................ ........................................... ............ 1
4 016452 SHAFT (Referenceonly) ........................ ................................................................. .... ..................... 1
5 001094 RING - Retaining .............................. ..... ............ ......... ..... .... ............... ..... ..... ................................... 1
6 014712 WASHER- .515 i.d. x .750 o.d........ ...... ......... ................ ......................... ..... ................................... 1
7 196443 SPRING .................... .................................. .............. ................................... ..... ....... ....................... 1
8 186770 SCREW - Dowel ............................ ..... .... ..... ................ ..... ............... ..... .... ..................... ..... .............. 2
9 187056 SIDE JOGGER - OS ... ........................ ..... ..... .... ...... ..... ............... .................... .... ............................... 1
10 195401 BUSHING .................. .......................................................... ......................................... .................... 2
11 101023 RING- Retaining .............................. ..... .......... .. ......... ..... .... ......................... ............ ....................... 2
12 401232 KNOB ........................ ................................................. ..... .... ......................... ..... ............................... 2
13 187058 SIDE JOGGER- nos . ....................................................................................................................... 1
14 186750 TIE BAR- Chain Delivery .................................. ..................... .......... .................... ............................. 1
15 100969 "C" Ring ........................................................... ...... .... .......... ...... ...................................................... 3
16 196444 SPRING .................... .................................. ................... .............................. ................................... 1
17 001771 WASHER- .375 i.d. x .875 o.d............................................ .............................. .............................. 1
18 001080 RING - Retaining .............................. ..... ............ ... ........... .... ......................... ............ ....................... 1
19 173835 SENSOR MOUNTING BRACKET ASSEMBLY ......................................................... ...................... . 1
20 402625 SWITCH PROXIMITY ASSEMBLY ................................................................................. ................ . 1
21 001589 SCREW . 8-32 X 1/4" ........................ ................. .. ..... ...... .... ......................... ............ .. ...... ............... 3
22 112521 SCREW · 4-40 x 3/4" ............. ................ .................... .......... .... ................ ........................................ 2
23 014520 RING- Retaining ....... ...................................................................................................................... 1
24 102527 SCREW ...................................................... ..... ..................... ........................ ................................... 1
25 186663 SPACER - Cam ..................................... ..... ..................................................................... ................ 1
26 001650 SETSCREW .............. ............................................................................................. ... ....................... 1
27 173752 PIN ·- Locator ....... ........................................ ..................................................................................... 1

CHAIN DELIVERY
1
2

CHAIN DELIVERY
FRONT JOGGER
Index Pa rt
1 101023 POST - Spring .... ................... ........... ............................................................................................... 2

2 195401 NUT - Hex with Lock Washer ............................ ............................................................................. 2
3 187056 SIDE JOGGER ASSEMBLY, o.s. ..... ........................................ .................... ....................... ...... ...... 1
4 187058 SIDE JOGGER ASSEMBLY, n.o.s............................................................................................. ...... 1
5 187352 JOGGER ROLLER ASSEMBLY ....................... .......... ..... ...... ........................................................... 1
6 001749 WASHER .............................................. ................ .......... .... ........... .............................. .................... 1
7 001060 RING - Retaining ............................................................................................................................ 1
8 102350 SCREW · Black, 10-32 x 3/4", #36 .. ..... ............ ........ .... ....... ........................ .... ............................... 1
9 187360 POST - Spring .................................. ..... ........... ... ..... ..... ..... ............................................................ 1
10 102538 NUT- Hex, 1/4-20 .......................................... ................................................................................. 2
11 187072 LEVER - Jogger Arm Assembly ................. .... ........... ..... .... .......................... .... ................ ............... 1
12 187359 POST - Spring ................................................ ............ .... ..... ......................... ............ ....................... 1
13 187077 TRACK - Bottom ....... ....................................................................................................................... 2
14 187347 LEVER ASSEMBLY - Front Jogger .... ........................ .... ................ .............................. .................... 1
15 187077 T .. ............................................................... .... ................ ..... ................... ............ .. ..................... 2
16 187347 L .. ................. ....... ....................... .............................. ........... ...................................................... 1

CHAIN DELIVERY
SPROCKET SHAFT ASSEMBLY
Index Part
1 016397 LEVER - Tension ............... .............. .......... ..... .............................. .......................... ....................... 1
2 001076 RING - Retaining .............. ................ ..... ........................ .............. ...... .......... .... ............................... 1
3 186604 STUD - Pivot .................................... .... ........... ................................................................................. 1
4 186613 DISCASSEMBLY ................................. ...... ..... ............................................. .................................. 1
5 195236 BEARING .......................................... ...... ................... ..... ..... .................... ..... ....... .. ..................... 1
6 014761 WASHER ......................................... ..... ................ .......... .... ........... .......... ..... .... .......... ..................... 1
7 014513 RING ...................................................... .................... ........... ..... ......... ..... ...... .... .............................. 1
8 190157 SPACER ............ ............................... ........ ....................... ......... ............... ..... .... ........ .. ..................... 2
9 081836 SPRING ................................................. ..... .......... ..................... ..... .............. ................................... 2
10 081623 RETAINER- Spring ........... ........... ............................................ ................... ................................... 2
11 186622 SHAFT - Idler ..... .............................. ..... .... ....................... .... ..... ............... ..... .... ........ .. ..................... 1
12 001784 RING - Snap ................................................... .. ........ ..... ............... .......... .... ............... ..................... 1
13 186585 RELEASECAMASSEMBLY .......... ................ ................................................... .............................. 1
14 190220 SPRING ................................................................ ................ ..... ..... .... ..... ........... ......... .................... 1
15 197422 WASHER· .636 i.d. x .862 o.d .......................... .. .......... ..... ......... ..................... .............. ................. 2
16 001094 RING - Retaining ............................................ ...... ............... ......... ...... .......... .... ................ ............... 2
17 186586 ARM- Roller Guide ................................................... ..... .......... ...... .............. ..... ........... .... ............... 1
18 100716 NUT - Lock ................................................................................................. ........... ......................... 2
19 102261 SCREW- 6-32 X 7/8" ....................................................................................................................... 2
20 172766 SPROCKET ASSEMBLY ................................ ........... ......... ............................................................ . 1
21 195236 BEARING ..................................................... .... .......... ..... ......................... ..... ....... .. ..................... 1
22 014761 WASHER· .628 i.d. x 1.000 o.d ...................................................................................................... 1
23 014761 WASHER· .628 i.d. x 1.000 o.d ...................................................................................................... 1
24 001784 RING - Snap ..................................... .... .......... ...... ..... ..... ............... .......... .... .................................... 1
25 016398 LEVER - Tension ............................. .... ...... ..... ................................................... .............. ............... 1
26 172769 WASHER- Special ............................................................................................... .......................... 1
27 172769 WASHER - Special ........... ........................ ......................................... ..... .................... .................... 1
28 001784 RING - Snap .................... ................. .... .......... ................................... ..... .... ..... ............................... 1
29 186588 HUBASSEMBLY ............................................................................................................................ 1
30 102357 SCREW- Black Oxide, 10-32 x 1/4" ........... ... ................................................................................. 1
31 197048 WAVEWASHER ....... ..................................... .................................................................. ................ 2

CHAIN DELIVERY
12
11
2
10
9 ---./
6
5

CHAIN DELIVERY
BACK STOP ADJUSTING SHAFT
Index Part
1 001986 PIN · Roll ............ .............. ............................................................................................................... 1

2 186751 KNOB ................. .............................. ..... ..... ..... ......................... ............... ..... ............ ....................... 1
3 016933 KNOBASSEMBLY ............ ...... ................................................. ................................ ... .................... 1
4 017583 KNOB - Back Stop Adjustment ....... ........................................................................ ....................... 1
5 101916 INSERT .............. ................ .... ............... ..... .......... ................ ..... .... ..... ..... ..... ................................... 1
6 016574 WASHER - .315 i.d. x .687 o.d... ..... ...... .... ......... ........... ..... ..... .... ................ ..... ............................... 1
7 186540 PLATE - Mounting .............. ..... ......... ........... ..... ..... .... ................ .............. ..... ................................... 1
8 075443 CLAMP- Tube .... .............................. ..... ..... ...... ... ...... ..... .... .................... ..... .............. ..................... 2
9 186606 BEARING · Sleeve ............. .... .......... ...... ..... .... ...................... ..... .... .......... ..... .......... ......................... 1
10 102340 SCREW - 5/16-24 X 5/8" ... ..... .......... ...... ......... .. .. ...... .............. ................ ..... .... ............................... 6
11 025205 WASHER- .328 i.d. x 1.000 o.d ............. ........... .. ...... ..... ..... ......................... ............ ...................... . 6
12 179575 STANDOFF ....................... .... ................ ............... ..... ..... ...... ......... ..... .......... ..... ....... .. ..................... 3
13 186620 WOIRMGEARASSEMBLY ... ..... ..... ..... ...... ..... .... .......... ..... ..... ...... .... ..... ..... ...... ............................... 1

CHAIN DELIVERY
0 0 0
0 0
0 0
0
0
~ @
0
0
0
0 0 0
0
0 0
0
0 0
6
6 0 0 0 0 0
0 0

CHAIN DELIVERY
JOGGER MECHANISM
Index Part
1 186753 CHAIN SHAFT ASSEMBLY ............................................ .......... ............... ................. ... .................... 1
2 101281 PIN- Drive Lock ................................. ..... .......... ..... ...... .... .... ........... ...................... ....................... 1
3 000014 PIN- Taper ........................ ................ ......... ...... .................... ............... ............................ ............ 1
4 186610 MOUNT - Pawl, Sub-assembly .... .............. ..... .................... ................ ............................................ 1
5 186603 D.R. LINK ASSEMBLY ................................................ .... ..... ............... ...................... ....................... 1
6 001095 RING - Retaining .................................................. ..... ...................................................................... 2
7 186620 WOIRMGEARASSEMBLY ..... ......... ..... ........... ..... ......................... ..... ......... ................ .................... 1
8 186615 GEAR - Worm ........................................................ ..... ..... ............................................................ 1
9 186618 CLUTCH AND BEARING - Roller ................ ................ ............... ................................................. 1
10 186440 SPACER · Inner ................. .................... ......... ...... ..... ..... ...... ..... .... ................ .................................. 1
11 186439 SPACER - Outer .. ............................. .............. ................ .... ...................................... ........ .............. . 1
12 186444 COLLAR ................................................ ..... .... ...... ..... ..... ................................................................ . 1
13 102357 SCREW - Set, 10-32 x 1/4" ................... ............... ......... ............................................. ..... ................ 1

CHAIN DELIVERY
5 -- .
6, 7 --

CHAIN DELIVERY
WORK LIGHT RETROFIT KIT
Index Part
1 102332 SCREW · Black Oxide, 10-32 x 3/8" ........... ... ... .. ..................................................... ....................... 2
2 172310 BALLASTTRANSFORMER ASSEMBLY ...................................................... .... ............................... 1
3 172292 DEFLECTOR LIGHT- Chain Delivery ... .............................................. ..................... ....................... 1
4 254377 LAMP - Fluorescent ............ ........................ ..... ............................................. ............... .................... 1
5 172632 LAMP SOCKET ASSEMBLY ............ ..... .... ........ ....... ...... ..... .... .......... ....................... ....................... 1
6 102348 SCREW- Black Oxide, 6-32 x 1/2" .. ................. .. ................ ............................................................ 6
7 001805 NUT- Hex, 6-32 .. ................................................... .... ...................................................................... 3
8 250205 CLAMP - Cable ... .................................. .... ...... .. ........ .... ..................... ......... .................................... 1
9 001805 NUT- Hex, 6-32 ..................... ......................... ...... ..... ..... .......... ....................................................... 1

CHAIN DELIVERY
1~3
2 ~~ 4
~- s
_,-- 9
6
7
13,14
15
18

CHAIN DELIVERY
CHAIN DELIVERY RATCHET AND WORM GEAR
Index Part
1 001047 RING • Snap ...... .............. ...... ........... .... .......... .............................. .................................................. 1
2 001755 WASHER ............ ................................................. ........................................ .... ............................... 2
3 186616 BUSHING ...................................................... ................................................................................. 1
4 014461 RETAINING RING - #4 ..... ..... .......... ............... .. .. ...... .................... ............................. ..................... 1
5 186767 CRANKSHAFT ASSEMBLY ............ ..... .... ........ ....... ........... .............................. ....... .. ..................... 1
6 173248 BRACKET ASSEMBLY ....... ................. ........................ ............... .................................................... 1
7 111055 SCREW. 10-32 X 5/8 " ............................................. ................................................ .. ..................... 2
8 081609 CRANK - Pin .................. ............................. .................... ...... .............. ................ ............................. 1
9 186609 PAWLMOUNTSUB·ASSEMBLY ..... ................. ... ................... ............... ......................... ................ 1
10 081567 PAWL ............................................................................................................................... ............... 1
11 001049 RING - Retaining .............. ................................ ... .......... ..... ......................... .... ............................... 1
12 081833 SPRING - Pawl ................................................. ... .......... ................................................................. 1
13 016415 WORM AND MOUNT ASSEMBLY ..... .... ........................................................................................... 1
14 186770 SCREW · Dowel ................ .............. ........... ..... ................ ..... ........................................................... 2
15 001920 PIN ·Taper ....................................... ..... ......... ............ ..... .... ..... .... ...... ............................................. 1
16 001981 PIN - Roll .......................... .............................. ................................... .............................................. 1
17 196398 BEARING- Flange ........... .............................. .. ............ ................................... ................ .............. . 1
18 001432 BEARING ......................... ................ ..................... ..... ......... ..... ........... ............................................. 1
19 253375 SOLENOID ..................................................... ................................................................................ 1
20 111034 SCREW • 8·32 x 3/8" ....................................................................................................................... 2
21 186438 CONTROL LEVER ASSEMBLY ...... ............ ..... ......... .......... ............... ............... ....... .. ..................... 1
22 190713 PIN - Socket Link ............................................ .. ........ .... ........... ............... .... ..................... ............... 1
23 014515 RING - Plastic ........................................................................................................ .......................... 2
24 077837 SPRING - External ...................................... ..... ..................... .............................. ............................. 1
25 014520 RING - Retaining ............................................ ................................................................................. 1
26 173832 BRACKET- Solenoid Mounting ............................................................................ ... ....................... 1
27 102332 SCREW · Black Oxide, 10-32 x 3/8" ................... .................... ................ .......... ....... ....................... 3

CHAIN DELIVERY
9
8
7- ----r--......
6 -----.---......._____ __..;~')r------, 10
12, 13, 14
23 15
16
17
18
19, 20
21
22

CHAIN DELIVERY
CHAIN DELIVERY SPROCKET ASSEMBLY
Index Part
1 173645 WASHER ............ .............. ..... .......... ................................................................................ ................ 3

2 001688 SCREW - Sems ................................................ ........................... .................................................. 1
3 173661 SPRING· Wave ...................... .............. ......... .................................................................................. 1
4 173668 RETAINER - Spring ..................................................................................... ................... ................ 1
5 179637 ENCODER ASSEMBLY .................................. ...................... .............. ...................... .. ..................... 1
6 172755 STUD - Encoder Shaft ....... ................................ ............ ................................................................. 1
7 172756 BRACKET- Encoder ................................................ ...................................................................... 1
8 111075 SCREW - Hex Washer ............................... .... ................ ..... ......... ................................................... 3
9 172753 HOUSING - Chain Delivery Bearing ......................... ........................ .............................................. 1
10 014712 WASHER ............................................................................................................................ ............ 3
11 186771 DRIVE SHAFT AND SPROCKET ASSEMBLY ............................... ............................... ................... 1
12 100609 SCREW .................... .......................................................... ........... .... ........................ ..................... 3
13 001731 WASHER - Lock .................... ............... .......................................................................................... 3
14 005620 WASHER ........... ........................................................... ................ ............................. ......... ............ 3
15 172740 SPU RGEAR ........... ......................... ...... ......... ...... .......... ..... ............................................................ 1
16 100806 SCREW - Socket Head .................................................................................................................. 1
17 172753 HOUSING - Bearing, Chain Delivery ........................................... .... .............................................. 1
18 102238 BEARING - Ball .................................................................. ............... ................ ............................. 1
19 196955 WASHER ........................................................................................... ................................. ............ 1
20 102254 SCREW • 5/16·24 ................................................ .................................................. .......................... 1
21 001065 RING - Retaining ............................................................... ................ .............. ........ .. ..................... 1
22 102250 RING · Retaining, Black ........ .......................................... ......... ............... ........................................ 1
23 102249 PIN -Taper ............... ....................................................................................................................... 2
24 196850 WASHER - Thrust .......................................................... ..... ............... ............... ....... .. ..... ................ 1
25 001786 RING - Retaining ...... ............. ......................................................................................................... 1
26 172758 HUB ........................ ................................................................................................. ....................... 1
27 186605 CAM - Chain Delivery ..................................................................................................................... 1
28 014111 SCREW - 1/4-28 x 5/8" ......................... ................................................... ........................ ................ 4

CHAIN DELIVERY
1
2 5
3 6
11

CHAIN DELIVERY
BACK STOP ASSEMBLY
Index Part
1 016299 HOUSINGASSEMBLY ..... ..... ......... ................ ......................... .... ............................ ....................... 1
2 102332 SCREW · Black Oxide, 10·32 x 3/8" ............................................. .................................................. 4
3 100969 E-RING .............................. .............................. ......... ................ ....................................................... 2
4 100731 NY LINER ......... ................. ......... ..... ...... .......... .. ............................ .............. ............. ... .................... 2
5 141573 ROLLPIN ............ ...... ............................ .... ................. ..... .... .......................... ................................... 1
6 186755 BACK STOP SHAFT ASSEMBLY ... ..... .......... ...... ........... ..... .................................... .. ..................... 1
7 187356 JOGGER & RACK ASSEMBLY ....................... ..... ..... ..... ..... ........... ................................................. 1
8 196399 ROLLER ................................................ ............ ........ ..... ...... ........................................................... 1
9 001776 SNAP RING ........ ........... ......... ............... ..... ..... ..... .......... ................................................................. 4
10 016431 SHAFT .............. ..... ............................................................ ........... .................................................. 2
11 016430 ROLLER - Rear .. ............... ................ .... .... ...... ........... ..... .... ............................................................. 1

BASE

BASE
I
7 I
~ ---- ~ 10,11
,~)
"-... /
1

BASE
FEED TABLE MOTOR AND POSITION CONTROL ASSEMBLY
Index Part
1 173425 TABLE LIFT ASSEMBLY GEAR MOTOR ..................................................................................... 1

2 187499 GEAR MOTOR· Table Lift ........... ................... ......................... ..... ......................... ..................... 1
3 250205 CLAMP - Cable ............................................................................................. ....... ....................... 1
4 197416 PIVOT · Snap .. .............. ..... ......................................................................................... ................ 2
5 102309 SCREW ....................................................... ................................... ........................ ..................... 2
6 102383 SCREW- Phillips, 10-32 x 1/4" ................................................................ ............ .. ..................... 2
7 178259 SUPPORT- Gear Motor ............................................................................................................... 1
8 014249 SCREW- Set .................................................................. .............................. ....... .. ..................... 2
9 173431 COVER - Encoder Bracket .................................................... ...................................................... 1
10 100228 NUT ............................................................. ................................................................................ 2
11 102383 SCREW - Phillips ........................................................... ..................................... .. ..................... 2
12 173427 STANDOFF ................... ............................................ ................................... ....... .... ................... 2
13 173428 STANDOFF ................... ............................................................................... .............................. 2
14 173430 BRACKET - Encoder ...................................................... ......... ...... .......... ............ .. ..................... 2
15 014250 SCREW - Socket Head ................ ..... ......................... .... ........... .............................. ..................... 4
16 180422 DISK ASSEMBLY - Encoder ......................... .............................................................................. 1
17 178179 SENSOR ASSEMBLY- Encoder ............................................................. ............ .. .................... . 1
18 252527 PIN - Terminal ............................................................................ ........................ ..................... 4
19 253387 CONNECTOR ......................................................................................................................... 1
20 251191 SHRINK TUBE - #5 ................................. ................................................................................. 2
21 254262 SWITCH - Slotted Optical ............................................ .............. ................ ....... .. ..................... 1
22 173441 BRACKET - Gear Motor Assembly ............. ......................... ................ ........................................ 1
23 253383 CONNECTOR ................................................................................................... ...................... 1
24 253524 PIN· Contact ............................................................... ............... ............... ....... .. ..................... 2
25 173429 BRAKE - Gear Motor ........................................................................................ ....................... 1
26 173432 SPROCKET - #41, 10 Teeth, (Universal Feeder) .......................................................................... 1
27 197316 SPROCKET- 11 Teeth (Stream Feeder) ................................................................. ....................... 1
28 102405 SCREW - Hex Flange, 1/4-20 x 1/2" ................................................................................................ 4

BASE

BASE
COOLING ASSEMBLIES
Index Part
1 186897 FAN KIT ................... ......... ................... ..... 000000 00 000000000000000000000 00 000000000 0 1 00 00 00000000000000000 000 0000 0 0000 00 00 00 000000
2 186518 MOUNT- Fan, Feeder Base 1

oo oo . . . . . . . . . . oo . . oo oooooooo oo oo oooooo . . . . . . . . oo oooo o oo oooooooo oo oo oo oooo oo oo oo . . . . . . . . . oo . . . . . .ooooooo
3 014812 NUT- Keps ooooo . . . oo . . . . . . . . . oo . 24

. . oooo . . . . . . . oo . . oo . . . . . . . . . . . . . . . . . . oo . . . . . . . . . . . . . . . . oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ......... .. ....
4 102210 SCREW - Pan Head, 5/8 Steel Bla . .. .... 24

oo . . . . . . . . . . . . . oo . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . oo • • oo . . . oo . . . . . . . . . . . . . .oo • • •
5 102377 SCREW - 10-32 X 1/2" Black Oxid... 5

o o . . . . o o . . . . . . . . o o . . . . . . . . . . . . . . o o . . o o . . . . . . . . . . . . o o . . . . . . . . . . . . . . o o . .. . . . . o o o o o o o o . . . . . . . . .
6 186511 HEAT SHIELD (Universal) oo . . . . . . . . . oo oo . . . . . . . . . . . . ... . 1

.. ...................... . ............. .. ......... . . . . . . . . . . . . . . . .oo . .oo . . . . .
6 187566 HEAT SHIELD (Stream Feed) .... 0000000000000000 . . . 00 . . . . . . . . . . 000000000000000 . 1 . . oo . . . . . . 000000000 . . . . oo . . . . 0000 0 00 000 00 00 0000 . . .
7 186895 TWIN FAN ASSEMIBLY ................ ............... 1

00 oo . . . . . 00000 . . . . . . . . . . . 0000000 00 . . . . . oo . . . . . . . . . . . . . . . . . . . oo . . . . . . oo . . . . . . . . . .
7A 186898 BRACKET - Twin Fan ..... oo . . . . . . . . . ·oo · · · 0000 . . . .00 . . . . oo oooooooooooooo . 1 . . oo . . . . . . . . 0000 0 00000000000 . . . . . . . . 00 . . . . . 00 00 00 . . . . . . .oo
8 187578 CABLE ASSEMBLY- Twin Fan 2

oooooo oo oooo oooo• • oo oo oooooooooooooo . . . . oooooooooooooooooooooooo oo oo oo oooooooo oo oooo oo oo . . . . . . . .
9 102318 SCREW- 10-32 X 3/8" Black #36 3

oooooooo oooo oo oo · oooooooooooooooooooooooooooooo oo oo . . . . oo . . . . . . oo . . . . oo . . . . . oooo . . . . . . . . . . . . oo.
10 001052 WASHER 00 00 00 . . . . . . .. 3
. . . . . o o . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . o o . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . .
11 187567 HEAT SHIELD (Universal and Stream Feed) 1

oo . . . . . . . . . . . . oo . . . . . . . . . . . . . . . . . . . . . . . . . . oooo . . . . . . . . . . . . oo oooo oo oooooooooo
12 150084 NUT ................................ ........... ..... .................... ....................................... ..... ........... ..... .............. 4
13 102405 SCREW ............................................ ..................... .................... .............. ............... .... ................. 4
14 180963 RADIATOR ... oo.oo . . . . . . . . . . . oo oo oooooooooooo oo oooooo . . . . . . 1
oo . o o . . . . . . . . oo. oo ooooooo oo oooooo oo . . . . . . . . . . oo . . . . oo . . . . . oooo ooo oo oo oooooooooo00
15 186517 BRACKET - Mounti ng, lntercool 00 00 00 00 000 0000 0 000 000 00000 0000 00000 00000 0000 01 000 000 00000 0000 00000 0000 00 0000 0 00 00 00000000 . . oo . .. .
16 197397 BRACKET - Brass .. 2

0 0 0 0 0 0 0 0 0 0 . . . 0 0 . 0 0 0 0 . 0 0 0 0 00 0 0 0 0 . . . . . 0 0 . . . . 0 0 0 0 0 0 0 0 . 0 0 0 0 . . . . . 0 0 0 0 • • 0 0 0 0 0 . . 0 0 0 . . 0 0 . . . . . . . 0 0 0 . . . . . 00 00 00 00 00 00 00 00 00 . . .
17 254305 GUARD- Fan 10" ........................................ ....................................................................... 4 0 0 . .. . . . . .
18 187010 BASEFANASSEMBLY ............. 2

oo . . . . . . . . . . . 00 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . .oo . .. .. .. ..
19 187011 CABLE ASSEMBLY - Base Fan ........ 2

00 . . . . 00 . . oo . . . . . . . . . . . . oo . . . . oo . . . . . . . . . . . . . . . . . . . . . . 00 . . . . . . . . . . . . . . . . . 00 . . 0000 0000.
20 253277 CONNECTOR - P6072 .. ..... 00 00 . . oo . . . . . . . . 3

. . . . . . . . . . . . . . . . . . . . . oo . . . . . . . . . . . . . oo . . . . . . . . . . . 00000 . . . . . . . . . 0000 . . oo . . . . . .oo . . . . .
21 250203 CABLE CLAMP 00 . . . 2

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .oo 00 00 . . . .
22 186519 MOUNT - Fan, Mid/Del Base ...... 1

0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 00 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . . . . 0 0 0 0 0 0 0 0 0 0 . . . . . . 0 0 0 0 0 0 0 0 0 0 . . . . o o . . . 000000 00 00 00 0000 00 . . .
23 197570 PROTECTOR ........ 00 . . . . . . . . . . . . . . . . . . 00 . . . . .. .. .... .... . . AS REQUIRED

. . . . . . . . . . 00 . . . . . . . . . . . . . . . . . . . . . . . . . ............... . .........
*** Additional harnesses which are part of Fan Kit P/N 186897 are found in the Electrical Section of the
Parts Catalog.

BASE
19
18
13
12
23
+
+
11
10
9-6 Century 3S00 Parts Catalog

BASE
TUBING SCHEMATIC
Index Part
1 172713 TUBING- Black, .25 i.d. x .375 o.d. x 18" ....................................................................................... 1

2 178400 TUBING - Reinforced, .25 i.d. x .500 o.d. x 34" .................................... ................... ....................... 1
3 172713 TUBING - Reinforced, .25 i.d. x .375 o.d. x 23" .............................................................................. 1
4 197429 TUBING- Clear, 5/8 i.d. x 7/8 o.d x 13"............................................................... ........... ................. 1
5 178403 TUBING- Clear Vinyll, 5/8 i.d. x .906 o.d. x 27" ............................ ................... ................................ 1
6 180882 TUBING - Reinforced, 5/8 i.d. x .906 o.d. x 36" .............................................................................. 1
7 102280 FITTING- Tee Union, 5/8" ......................................................... ..................................................... 1
8 197429 TUBING- Clear, 5/8 i.d. x 7/8 o.d. x 77" ..................................... ..................................................... 1
9 180882 TUBING- Reinforced, 5/8 i.d. x .906 o.d. x 50" .............................................................................. 1
10 178403 TUBING- Clear, 3/8 i.d. x 5/8 o.d. x 27" ............ .............................................................................. 1
11 202708 CABLE TIE ....................................................................................... ............................ .................. 25
12 197429 TUBING - Clear, 5/8 i.d. x 7/8 o.d. x 17" ............................................... ........................................... 1
13 197327 TEE - 3/8" Tube ............................................ .................................................................................. 1
14 197429 TUBING- Clear, 5/8 i.d. x 7/8 o.d. x 26" ................................ .......................................................... 1
15 178403 TUBING - 3/8 i.d. x 5(8 o.d. x 27" ........ .... ...... .............................. ........................ .......... .................. 1
16 173395 TUBING- Pneumatic, 3/8 i.d. x 1/2 o.d. x 15" ..................................................... ............................ 1
17 173395 TUBING- Pneumatic, 3/8 i.d. x 1/2 o.d. x 12" ........................................................... ...................... 1
18 173395 TUBING- Pneumatic, 3/8 i.d. x 1/2 o.d. x 12" ................................................................................. 1
19 173395 TUBING- Pneumatic, 3/8 i.d. x 1/2 o.d. x 15" .................................................................................. 1
20 197429 TUBING · Clear, 5/8 i.d. x 7/8 o.d. x 30" ............ .............................................................................. 1
21 173395 TUBING- Pneumatic, 3/8 i.d. x 1/2 o.d. x 44" ............................ ..................................................... 1
22 197331 TEE - Tube, 5/8" ............................................................................................................................ 1
23 173395 TUBING- Pneumatic, 3/8 i.d. x 1/2 o.d. x 44" ....................................... .......................................... 1

BASE
8 ---------~~
-'
/'
II
9, 9A- -
7 --~
6---
18

BASE
UNIVERSAL FEEDER PUMP, COMPRESSOR & BASE ASSEMBLY
Index Part
1 197296 PULLEY .............. ................ ............................................................................................................. 1

2 172484 V-BELT .................................................................................................................... ....................... 2
3 172485 ISOLATOR- Vibration Mounting ...... ................................................................................................ 4
4 001833 NUT· 1/4-20 .......................... .......................................................................................................... 4
5 072822 PULLEY ...................................................... ..................................................................................... 1
6 186435 PUMP · Large Condenser ........................................................................................ ..................... 1
7 102423 FITTING NIPPLE- Close, 3/4 .......................................................................................................... 2
8 102421 FITTING · HOSE, 3/4 NPT ............... .......................... ...................................................................... 2
9 186437 FILTER JAR ASSEMBLY - 3/4 .............. ............ .............................................................. ................ 2
9A 187174 FILTER ELEMENT(Only) ...................................... ........................................................................... 2
10 150086 LOCKNUT .................................................................. ...................................................................... 4
11 102570 SCREW - Hex Flange 5/16-18 x 3/ 4" ........................................................................ .. ..................... 4
12 017858 AIRVACUUMMOTORASSEMBLY ...................... ............................................ .............................. 1
13 102482 FITTING- Elbow, 1/2-14 NPT .......... ..................... ..... ................................................. ..... ................ 1
14 102481 PIPE STEEL- 1/2 NPT x 6" lg......................................................................................................... 1
15 102422 FITTING· Hose, 1/2 NPT ................................................. ................ .... ............................................. 1
16 186436 JAR- Filter, 1/2" .................. ......................... ..... ......... ...................................................................... 1
17 197435 SILENCER - Exhaust ..................................... ....... ..... ...................................................................... 1
18 150084 NUT -1/4-20 ..................................................................................................................................... 4
19 186434 PUMP· Small Condenser ...................................................................................... ......................... 1
20 001740 LOCK WASHER .............................. ............... ... .. ..... ....................................... ........ .. ..... ................ 2
21 186431 WIRE- Ground Strap ................. .......................... .... ....................................................................... 1
22 187117 BASE ASSEMBLY ........................................................................................................................ . 1
23 187113 BASE - Blower System ................. ............... ...... .... .............................................. .... ................... . 1
24 102337 CARRIAGE BOLT -5/16-18 ..................... ......................................................................... ........... 4
25 187837 PLATE- Stroker Vacuum Pump ........................................................... .......... .............................. 1
26 187116 PLATE- Blower Pump ................................................................................................................. 1
27 001640 SCREW .............................. .......... ............................................................................................... 4
28 102526 SCREW · Hex Flng. Zinc Scr., 1/4-20 x 1/2" ............ ...................................................................... 2
29 102487 BOLT- Carriage , 1/4-20 ............................................ ..................................................................... . 4
30 197297 PULLEY - Two Groove ..................................... .. .............................................................................. 1

BASE
5 ------....
I
I ---- 2
~
4------
.....____ _ _ _ 8

BASE
PNEUMATIC AIR COMPRESSOR
Index Part
1 172499 COMPRESSOR ................................................................................................... ............................ 1

2 172498 ISOLATOR - Vibration ....... .... .......... ..... .... ....................................................................... ................. 4
3 014808 NUT - 10-32 .................................... ................................................. ............................................... 4
4 187232 WIRE- Ground Strap .................... ......... .............................. .............................. ............................ 1
5 001706 WASHER- Lock, .199 i.d. x .400 o.d . .......... ............... ..... ..... ...... .................. ............... ................... 1
6 196980 BARB - Elbow, Male ............................... ................ ..... .... ............................................................... 1
7 102405 SCREW - Hex Flange, 1/4-20 x 1/2" .......... ...... ......... .... ..... ...... ..... ................................................ 4
8 186674 SUPPORT - Compressor ......................... ........... ..... ..... .... .......................................................... 4
9 102526 BOLT- Hex Head .... .................................... ...... ......... ..... ...... ......................................................... 1
10 001740 STAR WASHER ................................. ........... .... ............... ............................................................... 1

BASE
2, 3, 4, 5, 6
1
0 0
0 0

BASE
BASEASSEMBLY-PART1
Index Part
1 102486 SCREW - Hex Flange, 3/8-16 x 3/4" .. .................... .... ............... ............... .............. ....................... 2
2 173259 1/R, P/S COMPRESSOR ASSEMBLY ........... ..... .......... ............... .................................................... 1
3 102303 SCREW- Hex Flange, 1/4-20 x 3/4" ........................................................... ......... .... ....................... 3
4 191797 WASHER ........... .............. .............. ................ .............. ................................................................... 8
5 150084 NUT .................. ............... .................... ..... .... ........... ...... .... ..... ................................. ..................... .. 4
6 102572 SCREW- Hex Flange, 1/4-20 x 1" ........ ......... ..... .......... .... .............................................................. 1
7 001706 LOCKWASHER ...... .. ............................................... .......... .............................................................. 1
8 187232 WIRE - Ground Strap ..... ............... .......... ......... ...... ..... .... .............................. .............................. .. 1
9 001740 LOCKWASHER .............................. ...... .............. .......... ................ .................................................. 1
10 102526 SCREW - Hex. Flng. Zinc, 1/4-20 x 1/2" .......................... ............................................................. 1
11 014158 SCREW - Hex Washer Head ......... ..... ............... ..... ..... ..... ............................. ................................ 4
12 172634 BRACKET - Compressor C. D ....... .............. ................ .... ........................................................... .. 1
13 150088 NUT ...................................... ............................................. ............................................................. 2
14 173488 DRIVEMOTORINVERTORASSEMBLY ...... ..... .......................... ................................................... 1
15 187213 PLATE Inverter Cables ................... ..... .......... ..... .... ..... ..... ........... ..... ......... ..... .............................. .. 1
16 102570 SCREW - Hex Flange, 5/16-18 x 3/4" .............. ............... .............................................................. 4
17 150086 LOCKNUT ........ .............. ............... ..... ......... ...... ............... .............................. ................................ 4
18 172277 YOKE - C. D .............................. ......... ...... ............... ..... ............................................................. 1

BASE
1, 2, 3 ----.J
2, 3,4, _ _..../
------11
6
7
~---- 5

BASE
BASE ASSEMBLY- PART 2
Index Part
186510 BASE ASSEMBLY- Complete (Not Illustrated) .......................... ................ .............. ...................... 1
1 173779 DISTRIBUTION BOX ASSEMBLY .. ............... .......... ...... ............... .... ................ ............... ................. 1
2 025205 WASHER ..................................................................................... .............. .......... .... ....................... 7
3 102405 SCREW - Hex Flange, 1/4-20 x 1/2" ................................................ ............................................... 7
4 188528 CONTROL BOX - Complete ................ .............. ...... ......................... .............................................. 1
5 081879 GLIDER ............................................... .......... ..... ............................................................................ 6
6 019627 PAD ......................................................................... ....................................................................... 6
7 001047 RING - Snap ..................................... ........... ..... ...... ........ ................ .............. ................................ 6
8 254530 CRADLE ............ .............................. ..... ............. ............................................................................ 10
9 197416 PIN -Cradle Mounting ........................................ ........................................................................... 10
10 102255 NUT- Hex, 3/4 x 10 .......... ............................................................................... ............................... 6
11 173211 STUD - Leveler ............................. ............... ..... .............................. .............. ............... ................. 6
12 400545 LABEL - Shock .................... ............................................ ........... ................................................... 2

BASE
18
16
17
~=-------------~=-------------------~==~-- 14

BASE
TANK & MANIFOLD ASSEMBLY
Index Part
1 197330 BARB - Beaded Hose, 5/8 1.0............... ..... .... ................................................................................. 2

2 197331 TEE - 3/8 NPT ..... ............... ................... ...... .......... ............................. ............................................. 1
3 197329 BARB- Hose 3/81.0............................. .......................................................................................... 2
4 196973 PLUG- Pipe ....... .............. ..... .......... ...... ........ ............................... ................ ................................... 1
5 197182 BARB · Male Conn . ......................... ..... ...... ...... ........ ..... ...... .............. ...................... ....................... 4
6 179808 MANIFOLD ........ ................................... ................ ........................................................................... 1
7 102403 SCREW- 1/4-20 X 5/8" ............................. ............ ..... ...................................................................... 2
8 186109 BRACKET- Blower Hoses .................. ...... .................. ...... .......... .... ................ .............................. 1
9 179767 SAFETY VALVE-Tank .................... ..................... ..... .... .................................................................. 1
10 101441 TEE- Pipe ............................................................ ........................................................................... 1
11 197395 FITTING- Male .. ............... .............. ..... ...................... .... ................................... ............................... 1
12 102306 NIPPLE · 1/4" x 1-1/2" NPT ........................................ .... ..... ........... ................................................. 1
13 173602 VESSEL- Pressure ............................... ............... ........................................................................... 1
14 253916 SWITCH - Pressure ......................... .... .......... .. ... ..... ..... ................................................................. 1
15 101374 CLAMP ................. ............................. ............... ........... .... .......... ................ .... ................................... 2
16 101440 NIPPLE - #4 .................................................................... .................... ............................................. 1
17 197396 FITTING- Male Elbow ....... .............. ..... ...... ..... .... ..... ..... ..... ........... .............. ................................... 1
18 101537 FITTING ...................................................... ......... ..... ..... .......................................... ....................... 1
19 179740 VALVE- Check ............................................................................................................................... 1
20 102322 SCREW · Hex Flange, 1/4·28 x 3/4" ................................................................................................ 5
21 150081 LOCKNUT ........ .............................. ...... .......... ..... ......... ................................... ............................... 4
22 110057 SCREW- Pan Head ........... .............. ..... ..... .......... ..... ...... ................................................................ 4

BASE
------8
-- J1IIIR
llllll:::l
' -9

BASE
DRIVE MOTOR
Index Part
1 254844 ELBOW- Pull, 3/4", Female .. .......... ................................................................................................ 1

2 254815 CONNECTOR ...... ...... ...................................................................................................................... 1
3 254838 LOCKNUT- 314" .................. ............. ...... .......................................................................................... 2
4 254836 NIPPLE- Close, 3/4" .............. ..................... ..................................................................................... 1
5 187226 CORD - Power, Drive !Motor .............. ..... .... ........ ........ .... ...... ..... ..... .................................................. 1
6 250077 STA- Strap ...... ............................. ............... ...... .......... ................................................................. 2
7 187215 CABLE ASSEMBLY . ........................................... ..... ......... ............................................................. 1
8 187201 MOTOR - A.C. 3 Phase, 3 HP .................... .................... ...... ........................................................... 1
9 187108 PULLEY - Drive Motor ....................... ..... ..... .......... ..... ...... ..... .... ....................................................... 1
10 254844 ELBOW- Pull, 3/4" Female ............................. ...... .............. ............................................................ 1
11 187200 MAI N DRIVE MOTOR ASSEMBLY .. ..... ...... .................... ..... ......................... ..... ....... .. ..................... 1
12 102474 SCREW · Hex Flange, 1/2·13 x 1" ...... .......... .. ............................ ........................... ....................... 4
13 102491 LOCKWASHER · 1/2 Ext. Tooth Zinc ................. ........................................................................... 1
14 102534 WASHER - Plain Zinc, 7/16 ........... ..... ......... ............ ..... ..... .... .......... .............................................. 4
15 174074 WASHER -GREASE FITIING ·(45°) .. ............... ........... ..... ..... .................... ............ ....................... 2
16 187109 MAI N DRIVE BELT .......................................................... ................ .... ............................................. 1

ELECTRICAL

ELECTRICAL
_,--- 5
4 - --....._
~J
.............
,,
'-""
(!i?
v· ,---<::.l
i.
~--
3
2_ ___J

ELECTRICAL
MAIN POWER TRANSFORMER
Index Part
No. No. Desc ription Quantity
1 187203 CAPACITOR ASSEMBLY- Bridge .. 00 • • •••• • •••• •• •• ••• •• •• •• ••••••• • • ••••• • •••• • •••• • •••• • 1
•••• •• ••• • •••• • •••• • ••• • • • • •••• • •••••• ••
2 187034 TRANSFORMER - Boost, Drive Motor ... ...... ................................................. .................... .............. 1
3 102191 SCREW- Hex Flange, 1/4-28 x 1/2" ............................................................................................... 4
4 187035 TRANSFORMER - Main Power ..... ..... ......... ..... ........................... ... .............. .................oo •....•oo .. oo ..• 1
5 102303 SCREW - Hex Flange, 1/4-20 x 3/4" ··········· oo···· oo·oo···· oo··· ···oo ····· .. ·····oo·····oo·· .. ·oooo .. oo.............. oo .. oo..... 7
6 187216 BRACKET • Distribution Box Support oo•oooo• oo •••.. oo oo oo•oo•· oo ..... oo •••oo•·
000000 oooo•· oo ..... oo• oooo••oo ••...•. 1
00 00 0000. 00 00
7 102405 SCREW· Hex Flange, 1/4-20 x 1/2" .................................... ...... ...... 4

00 • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • 00
8 187216 BRACKET - Distribution Box Support ........ oo .•.. •oooo .... oo •.. ...•......••... .. oo •.... oo •.. •.•. oo .. oo........ oo .... oo .. oo ..... 1
9 178993 CHANNEL - Distribution Box ··oo··· oo·····oo· ·oo·· oo··· ··oo· ····· oo··· ··oo ·····oo······oo·············oo ..oo..... oo .oooo .oooo•·oo···· 1
10 186427 SHROUD - Fan ... .oo . .............................................. .......... ............ ·······························oo·oo··············· 1
11 197416 RIVET- Snap .. ..... oo .. oo •.. oooo••...•...... •.... •oooo .... oo •.. ... oo ...... •... ... oo .... oo •..... oo .................... oo. •oooo .. oo •.... 3
0000 • • • •

ELECTRICAL
-- ------------------------
----------------------------------------~-
3
r---------------------------, ~
I I I
I ~ I I L
I I I

ELECTRICAL
ELECTRONICS BAY ASSEMBLY- PART 1
Index Part
1 173796 COVER - Cabinet ............................................................................................................................ 1

2 400545 LABEL- Shock ............................................................................................................................... 1
3 001681 SCREW- 6-32 X 1/4" ....................................................................................................................... 1

ELECTRICAL
~--2
VIE'vv' II A-A"
9
~I
I
I
I
I

ELECTRICAL
Index Part
1 173797 CONTROLLER ASSEMBLY- Tri-Motor .................................................................... ....................... 1

2 186980 HARNESS - Fan Power .................... ..... ..... ......... ........... ..... .............. ........... .... .............................. 1
3 250098 CLAMP - Cable ..................................... .......... ................................................................................ 1
4 197536 SCREW - 6-32 X 5/16" ...... ..... .......... ..... .............................................. ····· .... ................ .... ········· ....... 1
5 197540 SCREW - 10x3/8", Self-Tapping .............................. ..... ..... .... ........... .......... ..... ....... .. ..................... 1
6 250206 CLAMP - Cable ..................................... .......... .. ... ......... .................................................................. 1
7 186976 HARNESS (Main) ............................................................................................................................ 1
8 197534 SCREW - 8 x 3/8", Self-Tapping ...... ............................... ..... ..... ....................................................... 1
9 250206 CLAMP - Cable ....................... .......... .... ............ ... ..... .................... ..... ............................................. 1
10 250098 CLAMP- Cable ............................................................................................................................... 1
11 186975 CABLE .............................. .............. .................. ....... ..... ..... ...... .......... .............. .......... ..................... 1
12 186976 HARNESS ....................................... ............................... ........... ...................................................... 1
13 083706 BOA RD - Motor Control ........................ .......................................................................................... 3

ELECTRICAL
~--3
2 4
II'-- ....
't:l
• 't:l
1_____/
v em I
e I
e r-',
A A
~
ei I
e I
e
_/\.
r---1
A
~
91 I
e I
e ~
0 0
L......J L.-
i
VIEW "A-A"
8, 9
11 _ /

ELECTRICAL
Index Part
1 173797 TRI-MOTORCONTROLLERASSEMBLY ... ................................... ................ .................................. 1

2 197536 SCREW- 6-32 X 5/16" ....................................... .. ......................... .................................................. 1
3 173490 INTERFACE/DRIVER - 1/0 ............................................................................................................... 1
4 173495 CABINET ASSEMBLY ................................................................................................ ..................... 1
5 173492 SENSORS/DOUBLES PCB ASSEMBLY- Without Programmed Micro Controller (U6) ................ 1
5 187186 SENSORS/DOUBLES PCB ASSEMBLY- With Programmed Micro Controller (U6) ..................... 1
5A 187196 PROGRAMMED MICRO CONTROLLER (U6) ............................................................................ 1
6 173795 FANASSEMBLY ....... ....... ................................................................................................................ 1
7 187204 MOUNTING BRACKET- Main CPU ................................................................................................ 1
8 173500 PC BOARD- Main CP U Final Assembly (With P ROMs (U25, U20) .............................................. 1
9 173780 PC BOARD - Main CPU Assembly (Without PROMs (U25, U20) ......................... ..... ................ 1
10 187190 EPROM - Programmed (U25) ................ ..................................................................................... 1
11 254432 PROM - Decoder (U20) .............................. .................................................. .............. ................ 1
12 254211 STAND-OFF - 1/2 PCB .................................................................................................................... 1
13 202475 FINGER GUARD- Fan .. .... ......................................................................................... ..................... 1
14 001279 SCREW .................... ......... ............................................. ................ .... ............................................. 1
***SENSORS/DOUBLES: Final Assembly part number is on PROGRAMMED MICRO CONTROLLER (U6) as PCBA187186
, .. MAIN CPU: Final Assembly part number is on EPROM (U25) as PCBA173500.

ELECTRICAL

ELECTRICAL
DRIVE MOTOR INVERTER ASSEMBLY- PART 1
Index Part
1 173415 POWER CORD - Drive Motor J6023 ............................................................................................... 1

2 253329 CONNECTOR - 6-Circuit J6023 .................................................................................................... 1
3 186982 POWER CORD- Inverter P8415 ..................................................................................................... 1
4 254824 CONNECTOR- 9-Circuit Plug P8415 ........................................................................................... 1

ELECTRICAL
s-----/
'-------- 3

ELECTRICAL
Index Part
1 173488 DRIVE MOTOR INVERTER ASSEMBLY .......................................................................................... 1

2 172455 INVERTER· Drive Motor ........................................................... .................................................. 1
3 173418 HARNESS- Drive Motor Inverter Control Signal ........................................................................ 1
4 253393 J6005 - Connector, 12 Circuit ............................................................................ ..................... 1
5 187214 CABLE - Drive Motor Thermostat .............. ................................................ ....... .. ..................... 1
6 253388 J6029 - Connector, 4 Circuit .... ................. ......................................................... ..................... 1

ELECTRICAL

ELECTRICAL
Index Part
1 187214 CABLE ASSY - Drive Motor ............................................................................................................. 1

2 173418 HARNESS - Drive Motor Sig ............................ ............................................................................. 1
3 101374 CONNECTOR ................................................................................................................................ 3
4 173415 CABLE - Drive Motor Power .......................................................................................................... 1
5 186982 CORD - Inverter Power ....................... ............................... ............................................................ 1
6 187213 PLATE - Inverter Cables .. .............................. ..... ........................ ................................................... 1

ELECTRICAL
Top View
0 0
4 ---------'

ELECTRICAL
BRIDGE CAPACITOR ASSEMBLY
Index Part
1 187203 BRIDGECAPACITORASSEMBLY .......................................................................... oo . . . . . . . . oooooooo . . . . . 1

2 254163 BRACKET • Capacitor ........................................................... oo . .................................................. 1
3 254162 CAPACITOR .................................................................................................................... 00 . . . . . . . . . . 1
4 251520 BUSHING ..................................................................................................................................... 1
5 001693 SCREW . 8·32 X 1/4" o o o o o o o o o o o o o o o o o oo ooo oo oo ooo o o o o o o o o o o o o o o o o o o o o o oo oo oo o o o o o o o o o o ooo o o o o o o o o o oo oo oo o o o o o o o o oo o o o o o o o o o o o o o o o o o o o o 4
6 178366 HEAT SINK· Tapped ........... 00.00000 0000 0 00 000000000 0 000 00 00000000 00 00000000000000000000000000 0 0000000000000 00 000000000000000000 00 0 1
7 187202 BRACKET ASSEM BLY ·Heat Sink 0000 00 00000000 . . . . . . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . . oo . . . . . . . . . . o o . . . . . . . . . . . . . . o o . . . . . . oo . . . . o o . . o o o o o o . . . . . . 1
8 254154 BRIDGE • Full Wave, 30 Amp .. 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . . . . . . 0 0 0 0 0 0 0 0 0 0 . . . . . . 0 0 0 0 . . . . . . . . . . . . . . . 0 0 0 0 . . . . . . . . . . . . . . . . . oo . . . . . . . . o o . . . oo . . 1
9 101193 SCREW- 8-32 x 5/8" 00 00000000 00 00000000 00 00 00 00000000 00 00000000 0000 00 00 0000 0000 000000 0000 00000000000000000000000000 00 0000000000000000 1
10 172564 HARNESS · Bridge Capacitor, J6009, 6 circuit, from main transformer 0000000000 00 000000000000000000 00 00 0 1

ELECTRICAL

ELECTRICAL
DISTRIBUTION CABINET PC BOARD ASSEMBLIES
Index Part
1 173782 PC BOARD ASSEMBLY- Circuit Breaker ...................................................................................... 1

2 173784 PC BOARD ASSEMBLY- Power Distribution ................................................................................. 1
3 187018 HARNESS - Circuit Breaker ............................................................................................................ 1
4 254821 CONNECTOR - Socket, Terminal ................................................................................................... 2
5 254822 CONNECTOR - Socket, Terminal .................. ........... .......... ........... ................... ....... .. ..................... 2
6 254823 CONNECTOR- Socket, Terminal .................................. ................ .......................... .. ..................... 2
7 :254825 CONNECTOR - Socket, Terminal ............................................ ....................................................... 2
8 254826 CONNECTOR - Socket, Terminal .................. ................ .......................................... .. ..... ................ 2

ELECTRICAL
-------1
12 ~
4
5
--- 7

ELECTRICAL
DISTRIBUTION CABINET ASSEMBLY
Index Part
1 173793 DIST RIBUTION CABI NET ASSEMBLY .................................................................... ....................... 1

2 173784 PC BOARD ASSEMBLY- Power Distribution ................................ ......... ..... ............ ......... .............. 1
3 173489 POWER SUPPLY ASSEMBLY ........................................................... ............................................. 1
4 173792 COVER - Distribution Cabinet .. ...... ............................................................................................... 1
5 252537 CIRCUIT BREAKER - 8 Amp .......... ........... .... ........... ..... ...... .... ..... ............................... ................... 2
5 253543 CIRCUIT BREAKER - 4 Amp ................ ..... .... ...................... .... ............... .......... .............................. 6
5 254533 CIRCUIT BREAKER- 15 Amp .............................. .... ..... ............... .............................. ................... . 4
5 254534 CIRCUIT BREAKER- 12 Amp ....................... ............................................. ................ .................... 1
5 254543 CIRCUIT BREAKER- 5 Amp .................................... ..... ...... .................................... .... ................... 2
6 173782 PC BOARD ASSEMBLY- Circuit Breaker ............ ..... ..... .............................. ............... .................... 1
7 173794 PANEL CIRCUIT BREAKER ............ .... ......... ........... .... ..... ............................................................. 1
8 187230 JUMPER - Drive Motor Fuse with 2 Right Angle Terminals & 2 Straight Terminals ..................... 2
9 187221 JUMPER · Drive Motor Fuse with 4 Right Angle Terminals .......................................................... 2
10 254807 FUSE - 20 Amp ... ....................................... ..... ................................................................................ 2
11 253655 FUSE HOLDER - For 13/32" x 1-1/2" Fuse ..... ..... .... ........................................ ........... ................... 2
12 400545 LABEL- Shock ....... ........................................ .. ... .... ..... .............................................. .................... 1

ELECTRICAL

ELECTRICAL
POWDER SPRAY CONTROL PANEL
Index Part
1 42556003* KNOB - Black (A.B. Dick p/n 253932) ......... .... ................................................................................. 3
2 38 Panel* NUT - Jam ........................................ ..... .................................................. ..... .... ................. .............. 2
3 032HN-SPN* NUT - #10 Shake Proof ......... .......... ..... ...... .............................. ......... ...................... ....................... 2
4 2436009* BRACKET- Mounting (A.B. Dick p/n 174368) ............ ............................................... ....................... 1
5 WASHER- Lock ....... ......... .............. ..... ............ .. ................ ......................... ................................... 1
6 6762105A* INTENSITY POT ASSEMBLY (A. B. Dick p/n 174366) ............... ...................................................... 1
7 43453904* UNION - Reduction .. ............................................ ........................................ .................................. . 1
8 IRWL-Biue* LABEL- Wire ............ ....................... ................................... ................ .......... .............. ..................... 1
9 8-FR66* RESTRICTOR - Flow ................... .............. ..... ........................................................ .... ................... 1
10 CW-0805* CLAMP - Tubing ....... ......... .... .......... ...... ......... ........................... ................... ................................... 1
11 832HN-NYL* NUT- #8 Hex ....... .............................. .......... .......................... .............. ............................................. 1
12 14T38* TUBING- 21 .5" ................................ ........................................ .......... ......... .................................... 1
13 6831503* B.D.VALVEASSEMBLY .................. ...... ................................... .... ................ ................................... 1
14 14T38* TUBING- 5" ........ ...... ......... .............. ................................................................................................ 1
15 6955008* SHAFT SUPPORT ASSEMBLY ....... ................. .................. ......... ..... ................ .............................. 1
16 2979021* PLATE - Valve Mounting ........................................... ...... ..... .... ............... ........................................ 1
17 243601o· PANEL - Control (A.B.Dick p/n 174367) ..... ............................................................. ....................... 1
18 174191 LABEL - P.S./I.R ................................... .......... ................. .............. ........................... ....................... 1
*Contact Airtech

ELECTRICAL

ELECTRICAL
CONTROLPANEL-PART1
Index Part
1 187022 MAIN CONTROL PANEL ASSEMBLY ... ......... ... .. ..... ..................... .................................................. 1
2 187249 BEZEL - Control Panel ................. ........................................... ................ ..... .............................. 1
3 187020 ENCLOSURE - Operator Control Panel .................................. ................................................... 1
4 197407 WASHER .............. ....... ...... ........... .... ............... ...... ................... ................................................... 4
5 101197 SCREW ....................................... .......... ...... .. ........ ......................... ............................................. 4
6 254700 OYERLAY - Mechanical Switch Graphic ..... ....... ......... .............. ................................................... 1
7 :254701 PANEL - Membrane Switch .............................. ..... ...................................................................... 1
8 186896 BRACKET - Mounting ..... ........................ ............... ..... .............................. ................................... 2
9 001649 SEMS UNIT ..... .................... .............................. ..... ................ ......... ............................. ................ 8
10 254180 WASHER ....... ....... ....... .............................. ..... .............................................. .............................. 7

ELECTRICAL
Q
Q
Q Q
Q Q
Q Q
Q
(I
(I
(I
Q
(I
I)
Q
Q
a

ELECTRICAL
CONTROLPANEL-PART2
Index Part
1 187022 MAIN CONTROL PANEL ASSEMBLY ... ......... ... .. ..... ..................... .................................................. 1
2 172570 SHIELD · Control Panel RFI ......... ................... .............. .......... .................... ........... .................... 1
3 179618 PC BOARD ASSEMBLY, LED ....... ............................................................................................... 1
4 253044 STANDOFF ....................................... .......... ............................... .......................... ......... .............. 1
5 172875 SONALERT ASSEMBLY ............................. .................... .............. ................ .............. ................ 1
6 254182 STANDOFF ................... .............................. ......................................................... ......... .............. 6
7 001683 SCREW .............................................................................................. ........................ ................. 7
8 173501 PC BOARD ·Control Panel CPU Final Assembly (With PROMs U10, U11 , U5) ..................... 1
9 174152 PC BOARD - Control Panel CPU Assembly (Without PROMs U1 0, U11 , U5) ...................... 1
10 187192 EPROM · Programmed , Op. Code (U10) .................................................. .............................. 1
11 187194 EPROM - Programmed, English Language (U1 1) ...................... ...... ............ .. ..................... 1
***See Note 2
12 254433 PROM · Decoder (U5) .... .......................................................................................................... 1
13 172569 STRAP · Grounding ...... ................................................................................. ............... ............... 1
*** 1. The final assembly part number is on EPROM (U 10) as PCBA173501.
*** 2. English language EPROM (U11) can be interchanged with any one of the following language EPROMs:
German: PIN: 187041
French: PI N: 187043
Dutch: PI N: 187045
Japanese: PIN: 187047

ELECTRICAL
NOTE:
NUMBER INDICATES \
A GROUP OF PARTS
WHICH MAKE UP AN ____j
~
ENTIRE SWITCH. # L~

ELECTRICAL
CONTROLPANEL-PART3
187022 MAI N CONTROL PANEL ASSEMBLY ............................................................................................. 1
Index
No. Bezel Lens Diffuser Lamp Switch
2 253866, Std. Black 253862, Clear 254702, "Feed" 253868, 12V 253864, Switch 2
3 253866, Std. Black 253862, Clear 254706, "Water" 253868, 12V 253864, Switch 2
4 253866, Std. Black 253862, Clear 254706, "Water" 253868, 12V 253864, Switch 2
5 253866, Std. Black 253862, Clear 254707, "Ink" 253868, 12V 253864, Switch 2
6 253866, Std. Black 253862, Clear 254707, "Ink" 253868, 12V 253864, Switch 2
7 253866, Std. Black 253862, Clear 254708, "Image" 253868, 12V 253864, Switch
8 253865, Raised Black 253862, Clear 254709, "Start" 253868, 12V 253864, Switch 1
9 253866, Std. Black 253862, Clear 254708, "Image" 253868, 12V 253864, Switch 2
10 253866, Std . Black 253905, Red 254710, "Stop" 253868, 12V 253864, Switch 2
11 253866, Stdl. Black 253862, Clear 254711 ' 253868, 12V 253864, Switch 1
"Fwd. Inch"
12 253865, Raised Black 253860, Orange 254712, 253868, 12V 253864, Switch 1
"Rev. Inch"
Index Units per

No. Part Number Description Assembly
13 254766 Switch Actuator 1
14 174158 Mechanical 1
Switch PCB
15 101983 Sems Screw 3
16 253932 Knob 3
17 254765 E-Stop Switch 1
18 187248 Flat Washer 1
19 187211 Anti Rotation Washer 1

ELECTRICAL
4~
3---
@ TO E-STOP SWITCH
-,~ (#254765)
12 _ /
@ FROM MEMBRANE
SWITCH PANEL (#254180)
@ FROM SONALERT
ASM. (#172875)

ELECTRICAL
CONTROLPANEL-PART4
Index Part
1 187022 MAI N CONTROLPANELASSEMBLY ............................................................................................. 1

2 187228 HARNESS - Comm/Speed Control .. ................ ..... .......... ..... .... ...... .......... ............ ....................... 1
3 174160 HARNESS - Control Panel Interface .................................................................. ....................... 1
4 173416 SPEED CONTROL ASSEMBLY - J71 04 ............................................................. ........... ............ 1
5 253890 DISPLAY -2x20 MM ........................ ........... ......... ..... ..... ...... .... .................................................. 1
6 254687 BEAD - Ferrite ............... ..................... ............... ..... ...... .... ..... ....................................................... 2
7 014291 SCREW - Phillips .......... .................... .................... ..... ..... ............................................................ 4
8 178317 CABLE ASSEMBLY- CPU to LED PC Board ...... ..... ...... ........................ ............... ..................... 1
9 178319 CABLE ASSEMBLY - CPU to Display .......... ................... .......... .................................................. 1
10 178318 CABLE ASSEMBLY- CPU to Switch PC Board ......... ..... ........................................ .................... 1
11 250098 CABLECLAMP ................................. .......... .. ........ .... ................ .................................................. 1
12 001683 SCREW ........... ................................................. ..... .... ..... ...... .......... ......... ............... .................... 12
Century 3500 Parts Catalog 10-3 1

ELECTRICAL
1
------------------~------------------
/ El
\
El
oD DoD
~14
...----
~D D~
0 0
l
2 3

ELECTRICAL
INTER-TOWER AND FEEDER CONTROL PANELS
Index Part
1 187029 FEEDER CONTROL PANEL ASSEMBLY .. ..... ......... ................................... ................................... 1

1 187023 INTER-TOWER CONTROL PANELASSEMBLY ....... .......... ....................................... .................... 1
2 187083 BEZEL - Safety Movement ..... .......... ........................................................ ............................. ........... 1
3 254773 OVERLAY - Feeder Panel ................ ..... ......... .............................. ................ .... .............................. 1
3 254771 OVERLAY - Inter-Tower Panel ......... .............. .. ........ ..... .... .................................... .. ....................... 1
4 187027 BRACKET- Control Panel ........ ..... .... ............................... ........................................ ..... ................ 1
5 014295 SCREW - 6-32 x 3/8" ....................................................................................................................... 2
6 254860 SPACER - .375 ... ............................ ................ .. ........ .... ..... ...................................... .. .... ................ . 4
7 173502 PC Board - Universal Tower Final Assembly (With PROMs U , U ) .. .................... .... ................. 1
8 173786 PC Board- Universal Tower Assembly (Without PROMs U , U ) ................ ......................... . 1
9 187197 PROM · Strobe (U ) .................. .................................... .............................. .... ... .. ..................... 1
10 187198 PROM · Return (U ) ........................ ..................... .......... .................... .......... .......... .... ................ 1
11 001837 NUT- Hex, 6-32 ..................................... ............... .......... ................................................................. 1
12 187182 INSULATOR - Inter Tower Board ...... ..... ........... ..... .... ..... ................ .................... .... .... ................ . 1
13 006801 WASHER - (Inter Tower Panel Only) .... ..................... ..... ................................................. ................ 3
14 100716 INSULATOR- (Inter l ower Panel Only) ......................... ..... ............................................ ................ 3
*** Final part number does not appear on Universal Tower Board.
*** PCB jumper settings must be configured for intended application (i.e., feeder control panel assembly, tower one
inter tower control panel assembly, or tower two inter-tower control panel assembly).
Tower 1 Tower 2 Feeder

2
3 4
Jumper

ELECTRICAL

ELECTRICAL
BALLAST TRANSFORMER ASSEMBLY
Index Part
1 252793 HOUSING CONNECTOR 3ocircuit, P6032 (To power in) .................................... o....................... 1
0
2 253384 CONNECTOR 2ocircuit, P6033 (To lamp) ................................................................................... 1

0
3 200730 TERMINAL Ring, Ground Connection .......................................................................................... 1

0
4 254379 TRANSFORMER Ballast ............................................................................................................... 1

0
5 250077 STAOSTRAP ....... ...... 0 .... .. ....... .. ... .. ... .. ... .. ... . .. .. . . AS REQUIRED
....... .... .. .. ... .. ... .. .... . .. .... . .. .... .. .. ...............

ELECTRICAL

ELECTRICAL
DRIVE MOTOR AND CABLE
Index Part
1 187200 DRIVE MOTOR ASSEMBLY ............................................................................................................ 1

2 187226 CABLE · Drive Motor .......................................... ........................... .................................................. 1
3 253303 CONNECTOR · 6·Circuit, P6023 .................................................................................................... 1
4 187215 CABLE - P6029 ............................................................................................................................... 1
5 253390 CONNECTOR .................................................................... ............... ............................................. 1

ELECTRICAL

ELECTRICAL
COOLING ASSEMBLIES
Index Part
1 186897 FANKIT .............. ................ ........................ ..... ............................... .......................... ....................... 1

2 186518 MOUNT· Fan, Feeder Base .................... ....... .. ......................... ......... ...... ..... .............................. 1
3 014812 NUT· Keps ............ ........................ ..... ......... .............................. .................................................. 24
4 102210 SCREW - Pan Head, 5/8 Steel Bla... ..................... ................... ................ .................................. 24
5 102377 SCREW- 10-32 X 1/2" Black Oxid.... ...... ................... ..... ..... .................... ..... .............................. 5
6 186511 HEATSHIELD {Universal) ............ ............... ... .. .......... ...... ......... ................ ................................... 1
6 187566 HEAT SHIELD (Stream Feed) ............................ ........................................................... ................ 1
7 186895 TWIN FAN ASSEMBLY ............... ..... .... ........ ........ ..... .... ................ ......... .... ........... ..... ................ 1
?A 186898 BRACKET- Twin Fan ................ ...... .......... ...... .............. ................ .............. .............................. 1
8 187578 CABLE ASSEMBLY -Twin Fan .................... .............................. .................... ......................... 2
9 254530 MOUNTINGSTRAP-Universal ... ..... ..... ................ .... .................... ......................... ..... .............. .. 2
10 102318 SCREW -10-32 X 3/8" Black #36 ........... .... .......................................................... .. .................... . 3
11 001052 WASHER ....... ..... .. ............. ............................... ............... .............................. ................ ............. . 3
12 187567 HEAT SHIELD (Universal and Stream Feed) ........... .......... ..................................... ........ ............... 1
13 150084 NUT .................. .............................. .... ................ ..... ..... .... .......... ........... .... ..... ..... .. .... ..... .............. 4
14 102405 SCREW ........... .... .. ....... ................ ............... .. ............ ..................... .................... ......... ................ 4
15 180963 RADIATOR ...... .... .. ....................... .... ..... ..... ... ................. ................ ........................ ......... ............ 1
16 186517 BRACKET- Mounting, lntercool ... ............... ........... ..... ..... .................... ................. .. .................... . 1
17 197397 BRACKET - Brass . ....................................................................................................................... 2
18 254305 GUARD· Fan 10" .................................................. .......... ............................................................ 4
19 187010 BASE FAN ASSEMBLY .................... ......... .... .. .......... ...... ............... .... ........................................ 2
20 187011 CABLE ASSEMBLY - Base Fan .......... .... ........... ................ .... .......... ........................................ 2
20A 253277 CONNECTOR- P6072 ....................................... ........................................ .............. ................ 3
21 186979 HARNESS- Accesory Power ........ .... ........... ...... .... .......... ............... ............... ....... .. ..................... 1
22 253848 CONNECTOR · P8412, 8 Circuit, from Distribution Box to Static Eliminator ............................ 1
23 252387 CONNECTOR-J6071 ................................................. .................... ................ ......................... 1
23A 252387 CONNECTOR-J6070 .............................. .......... .... ......................... .......... ...... ......................... 1
24 253721 CONNECTOR - P8406, 6 Circuit, ................................ ...... .......... .................... ......................... 1
25 253286 CONNECTOR- P6025, 2 Circuit .... ............ .. ........... .............. ................................................... 1
26 253386 CONNECTOR - P6032, 3 Cicuit, from Distribution Box to Fa ns & Work Lamp ...................... . 1
26A 253386 CONNECTOR- P6031 , 3 Static Eliminator ............ .................................................................. 1
27 250203 CABLE CLAMP ..... ......... .............. ................ ...... .... .......... ........... ......... .......... ....... ... .... ................ 2
28 186519 MOUNT- Fan, Mid/ Del Base ........................................................................ ................................ 1
29 197570 PROTECTOR .. .............................................. ............... ............................. ............ .. ..... AS REQUIRED
30 197416 RIVET- Snap ... ...... ........ ..... ............... .... ................. .... ................ .......... .... .................................... 6
31 187011 CABLE ASSEMBLY - Base Fan ............................ ...................................................................... 1
32 253327 P8413A, Connects to J8413 on Distribution Box .............. .......... .............................................. 1
32A 253302 J8413A, Connect s to P8413 from Stream Feeder Control Box .......................... ..................... 1
33 252387 CONNECTOR- Connects to P6072 ... ....................................................................................... 1

ELECTRICAL

ELECTRICAL
D.C. POWER CABLE ASSEMBLY- N.O.S.
Index Part
1 187001 CABLE ASSEMBLY - D.C. Power .... ........... ..... ............................... .......................... ....................... 1
2 253729 CONNECTOR - P8418 ..... ......................... ........................................... ........... .............................. 1
3 250077 STA-STRAP ..................................... ..... ................... ................ .... ............................ ....................... 3
4 254160 CLAMP - Cable ... .............. .................... .......... .. ... ..... .................... .............................. .................... 2
5 254157 PLUG - ?-Circuit P9602 .................. ..... .... ................. ...... .... ............................................................ 1
6 254472 CLAMP - Cable ................. ................................ ... ......... ......................................... ......................... 3
7 :254157 PLUG- ?-Circuit J7102 ......................................... ............................................ .............................. 1
8 172665 CHANNEL- 3x2 Cable .................... .... ..... ...... .............. ..... ................ ......... ............... ..... ................ 1
9 197416 RIVET- Snap ........................................ .......... .. ... ..... ............... .............. ..................... .................... 7
10 014774 WASHER .............................................................. ........................................................... ................ 5
11 250077 STA-STRAP ..................................... ........... ............. .................... ............................ .. ..... AS REQUIRED
12 172680 COVER • Channel ........................... .... ........... .. ............................................... .......... ...... ............... 1
13 187176 CHA NNEL -2x2 Cable ........... ............................... ............................................................ ............... 1
14 187178 COVER - Channel ............ ............... ............... .. ........ ....................................... .......... ...... .............. . 1

ELECTRICAL

ELECTRICAL
PNEUMATIC COMPRESSOR ASSEMBLY
Index Part
1 172499 COMPRESSOR- with power cord to regulator ............................................................................... 1

2 186984 POWER HARNESS - Pneumatic Compressor ... .......................................................................... 1
3 253721 P8444 - Plug, 6-Circuit ................................................................................................................ 1

ELECTRICAL

ELECTRICAL
MOTOR DRIVE HARNESS- PART 1
Index Part
1 186993 MOTOR DRIVE HARNESS- Motor Inter-connect... ........................................................................ 1

2 253286 CONNECTOR - P6049, 2 Circuit... .............................................................................................. 1
3 250945 CONNECTOR - J71 01 , 37 Circuit .............................................................................................. 1
4 253387 CONNECTOR - P6021 , 4 Circuit ................................................................................................. 1
5 250077 STA-STRAP ..................................... ................ ................... ......................... ................... AS REQUIRED
6 254530 MOUNTING STRAP - Universal ....... ............................................................................................... 2
7 197416 RIVET- Snap .................................................................................................................................. 2

ELECTRICAL

ELECTRICAL
MOTOR DRIVE HARNESS- PART 2
Index Part
1 186993 MOTOR DRIVE HARNESS · Motor Inter-Connect.. ........................................................................ 1

2 172543 J91 04 - 75 Circuit .............. .......... ....................................................... ..... ............ ....................... 1
3 253898 P9603 - 4 Circuit ................ ............... ............ ................................. ............................................. 1
4 253286 P6000 - 2 Circuit, to Damp Motor 1 ...................................................................... ....................... 1
5 253277 P8416 - 3 Circuit, to Distribution Box ...................................... ..... .......... .................................... 1
6 253286 P6002 - 2 Circuit, to FD Raise/Lower Motor ...................................... ......................................... 1
7 253394 P6005 - 12 Circuit, to Inverter ....... ..... ....................................................... .................................. . 1
8 253277 P6022 - 3 Circuit, to Table Limit ................. ............................................. ............... ..................... 1
9 254842 SCREW -Jack (Female) .................. ........................................ ............... ................................... 1
10 253286 P6001 - 2 Circuit, to Dampener Motor 2 ................................. ................ ................................... 1
11 172548 CLAMP - Strain Relief ............................. ....................................... ....................... ....................... 1
12 250077 STA-STRAP ..................................... ........... ..... ........................ .................... ............ .. ..... AS REQUIRED
13 197416 RIVET - Snap ........................................ ................................... ..... .............................. .................... 8
14 254530 MOUNTING STRAP - Universal ...................................................................................................... 2
15 254472 CABLE CLAMP - 5/8" Dia . ............ .... ..... .......... .......................... ..... .... ............... .......... .................... 6

ELECTRICAL
1-------'
8 -----------'
2 -------~
7

ELECTRICAL
AIR SOLENOID HARNESS (NOS)
Index Part
1 186992 AIR SOLENOID HARNESS - nos ..... .......... .... ........... ............................................... ....................... 1
2 172542 P9114 - Connector, 34 Circuit, CPC, from Control Box ............................................................. 1
2 172547 SHIELD ....................................... ..... ........... .. ..................................... ............... .......................... 1
3 253388 P6041 - Connector, 4 Circuit, L14, 15 ........ .. ........ .................... ..... ........................ .... ................. 1
4 253392 P6042 · Connector, 9 Circuit, L12, L13, L20 .......................................... ............. .. ..................... 1
5 253388 P6040 · Connector, 4 Circuit, L16, L17 ...... .. .............................................................................. 1
6 253392 P6039- Connector, 9 Circuit, L19, L21 , L22 .............................................................. ................ 1
7 253384 P6006 · Connector, 2 Circuit, Oiler, L23 ............... ............................................... .. ..................... 1
8 253383 J6017 · Connector, 2 Circuit, J6017 ............... ...... ......................... ............................................. 1
9 250077 STA-STRAP ....... ................................................. ............................................................ AS REQUIRED
10 254530 MOUNTING STRAP - Universal ... .... .......... ............... ..... .............................. ...... ...... ........ ............... 2
11 197416 RIVET • Snap ...... .................................. ............................. .................... ..... ..... ...... .... .... ................ . 5
12 254472 CABLE CLAMP - 5/8" Dia ...................... ........................................................... .............................. 3

ELECTRICAL
'----- 2

ELECTRICAL
AIR/VACUUM POWER CORD
Index Part
1 186957 AIRNACUUM MOTOR ASSEMBLY- (For reference only) .............................................................. 1

2 172555 MOTOR ..................................................................................... .................................................. 1
3 172560 AIR/VACUUMPOWERCORD .................................................................................................... 1
4 253328 P3602 - Connector, 5 Circuit, P8409 ....................................................................................... 1
5 254530 MOUNTING STRAP - Universal ................. .... .................... ..... ........... ........................ ..... AS REQUIRED
6 197416 RIVET- Snap .................................... .... .......... .. ... ........................................................... AS REQUIRED

ELECTRICAL

ELECTRICAL
FEEDER HARNESS (OS)
Index Part
1 187004 FEEDER HARNESS - OS 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 OoOOOO 0 0 0 0 . . 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 000000 0 00 000 00 0 1

0000000000000 00
2 253387 S26·11 , S26·12 ·Terminal, to Feeder E-stop Switch 00 0000000000 0 0000000000000000 0000 00 00 00000000 00 00000000 00 0000 00 2
3 254403 L25·1 , L25-2 -Terminal, to Feed Solenoid 0000000000000000000000000000000000000000000000000 0 0000000000000 0 00000000000000 0 2 0
4 252793 J6050 - Housing Connector, 3 Circuit, to Feed Solenoid . 00000 • • oo 0000000000000000. o • • oo 00 000 0000 ooo . 1
00000000 . . . . o
5 253387 J6024 - Connector, 4 Circuit, to Feeder E-stop 000000 0000 00 0000 000000 000 00 00 00 0000000000 00000000 000 00 00 00 00 0000000000000 1
6 253387 S26-21 , S26-22 -Terminal to Feeder E-Stop Switch 0000000000 00 00000000 00 00000000000000 00 00 0 2
00 000000000000000000000
7 :250077 STA-STRAP 00 0000 0000 0 0 00 00000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000000 0 AS REQUIRED

8 250306 CLAMP - Cable 00 0 0 00 00 . oo 0 0000 0 00 00 00 00 00 0 00 00 0 00 00 00 00 0000 . . 00 000 00 00 0 00 00 00 00 0 . . 00 0 0000 . . 00 . . o 0000 0 0000 . . 00 0 . . 0 0 0 0 . .. . 0 4
000 00 00 00 000 00 00 00 0 0
9 001220 SCREW ooo ooo oooo o o o o o o o o o o o o o o o o o o o • • o o o o o o o o o o o o o o o o o o o o o o o o o o O o o oo o o o o o o o o o o o o o o o o o o o o o o o o o o o o o oo o ooo o o ooooooo •• ooo ooo oooooooo o 4
oooo oo oooooo • • oo

ELECTRICAL

ELECTRICAL
AC DEVICE CONTROL HARNESS
Index Part
1 186997 AC DEVICE CONTROL HARNESS 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 OoOOO 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1

0000000 000000000 0000 000
2 254829 P9107 · Connector 000000000000000000000000000000000000000 0 00000000000000000000000000 0 00000000000000000000000000000000000000000000000000 1

2 254833 SHIELD - Connector ooOOOooOOOOOOOOooOOOOOOOOOOOO 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 OOOOOOOOOOOOOOOooOOOOOOOOOOOOOOOOOOOOOOOOOOO o o o 1
ooooooooooooooooooooooo
3 253384 P6026 - Connector, 2 Circuit, to Distribution Box 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 oOOOOO 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . 1

oo 00 0000 0000 00 0000 00 00 0
4 253286 P6051 - Connector, 2 Circuit, to Bail Bar Solenoid ooooooooooooooooooo oo oooooooooooooooooooooo o 1

oo oo oo ooooooooooooooooo
5 253386 P6050 - Connector, 3 Circuit, to Feed Solenoid 1

0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 . . o o OOOOooOOOOooOOOOOOOO 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0
6 250062 L26 - Receptacle, to Tower One Ink Duct Solenoid 0000000000000000000000000 0000000000000000 00 0 2
0000000000000000000000 0
7 250062 L24 - Receptacle, to Tower Two Ink Duct Solenoid ooooooooooooooooooo oo oooooooooooooooooooooo o 2
oo ooooooooooooooooooooo
8 254828 P9108 - Connector, 6 Circuit, to Electronics Bay Assembly 000000 00 0000000000000000000000 0 1

00000000000000000000000
9 253286 P841 0 - Connector, 2 Circuit, to Distribution Box 00 00 00 00 00 0000 00 00 . . 0000 00 000000 00 00 0000 00 00 00 . 1
00 00 0000 0000 00 0000 00 00 0
10 253327 P8414 - Connector, 4 Circuit, to Distribution Box 0 0 0 0 0 0 0 0 0 0 0 0 0 0 OOOOoOOO OO 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1

0000 0000 000000000000 000
11 250077 STA.-STRAP ooooooooooooo o oooooooooooooooooooooooooooooo oooo oooooooooooooooooooooooo . . . . o . . . . . . . oo . . ooooooooooooooooooooo oo ooooo AS REQUIRED

12 254472 CLAMP - Cable, 5/8". 0000 0000 0 000000 00000 0000 0000 0 0000 00 . . . . 0 0000 0000 00000 00000 000000 0000 0 0000 00000 00000 00000 000000 0 9
000 0000 000000000 0000 00 0
13 197416 RIVET - Snap 0 00 00 0 00 00 00 00 0 0000 0 00 00 00 0000 0 00 00 0 00 00 00 00 0000 . . 00 000 00 00 0 00 00 00 00 0 00 00 00 00 00 . 0 0 000 00 00 0000 0 00 000 . . 0000 . . oo 0 11
00000 00 00 000 00 00 0 00
14 254530 MOUNTING STRAP- Universal ooOOOOOooOOOOOOOOOO . . . . . . . . . . . . . . . . . o . . . . . . . . oooooOo o oo oo oooooooooooooooooooooo . . . . . . . . . . 0000000000000 2

ELECTRICAL

ELECTRICAL
A~ R SOLENOID HARNESS (OS)
Index Part
1 186991 AIR SOLENOID HARNESS - O.S. ... .............................. ................................................................. 1

2 172542 P9115 - 34 Circuit, from Control Box ...... ................................. ................ ................................... 1
2 172547 SHIELD .............................. ......... ..... ........... ....................................... ......................................... 1
2 254840 SCREW -Jack, Female ......... .............................................................................. ....................... 1
3 253388 P6048 - 4 Circuit, to Powder Spray .. .......................................................................................... 1
4 253388 P6036 - 4 Circuit, L 1, L2 ..................................................... ................ ........................................ 1
5 253388 P6035 - 4 Circuit, L3, L4 .................. .......................................................................................... . 1
6 253388 P6038 - 4 Circuit, L5, L6 ................................................. ............................................................ 1
7 253388 P6037 - 4 Circuit, L7, L8 ............. ..... ................................... ........................................................ 1
8 253384 P6003 - 2 Circuit, [)oubles Divert ..... .......................................................................................... 1
9 253384 P6030 - 2 Circuit, Raise/Lower Brake ... ......................... ............................................................ 1
10 253384 P6017 - to Oiler ........................................................................................ ................................... 1
11 254472 CLAMP - Cable, 5/8" Dia... .............................. ............................................................................... 3
12 197416 RIVET - Snap .................................................................................................................................. 5
13 250077 STA-STRAP ...... ............................... ..... ............................................................ .............. AS REQUIRED
14 254530 MOUNTING STRAP - Universal ....... ..... .................................... ..... .............. ................................... 2

ELECTRICAL
' - - 9, 10
'------1

ELECTRICAL
ACCESSORY POWER HARNESS
Index Part
1 186979 POWER HARNESS -Accessory .................... ................................................................................. 1

2 253721 P8406 - 6 Circuit, from Distribution Box ................................... .................... ..... .......................... 1
3 253386 P6031 - 3 Circuit, Static Eliminator .. ............................................................ .................. ............ 1
4 254401 L36 - to Heat Exchanger Fan .................................................................................. .................... 2
5 253386 P6032 - 3 Circuit, to Work Lamp .................................... ............................................................ 1
6 253286 P6025 - 2 Circuit ................................... .............................................. ........................................ 1
7 253848 P8412- 8 Circuit ........................................ .................... .......... ...... ............................................. 1
8 250077 TIE WRAP- Black ..................................................................................................... ....... AS REQUIRED
9 250356 CLAMP - Cable ................. ................................ .............................................................................. 4
10 197416 RIVET- Snap ...... .... .......... .................... .......... .. ............................................................................. . 6
11 254530 MOUNTING STRAP - Universal .......................................................... ............................................ 2

ELECTRICAL

ELECTRICAL
INTER-TOWER HARNESS
Index Part
1 186999 HARNESS- Inter-Tower .................................. ......................................................... ....................... 1

2 250931 J71 03 - 37 Circuit, from Control Panel ....................................................................................... 1
3 254161 CLAMP - Cable .................. .................................................................................. ........... ............ 1
4 254260 J3001A- 34 Circuit Modu, to Tower Two Panel Board .............................................................. 1
5 254260 J3001 C- 34 Circuit Modu, to Feeder Panel Board ...................... .............................................. 1
6 254260 J3001 B - 34 Circuit Modu, to Tower One Panel Board ...... ........................................................ 1
7 250077 STA-STRAP .......................................... ......... ... .. ......................... ................ ................... AS REQUIRED
8 254472 CLAMP- Cable, 5/8" Dia................................. .................... .................................... .. ..................... 2
9 197416 RIVET - Snap .......... .......... ......................................................................................... ..................... 2

ELECTRICAL

ELECTRICAL
SENSORS
Index Part
1 186990 SENSORCABLEASSEMBLY ......................................................................................................... 1

2 254830 P9111 - 104 Circuit, Bulkhead Connector from Control Box ....... .......... ................ .................... 1
2 254831 RELIEF- Strain ......................... ........ ................................................................... ....................... 1
2 254842 SCREW -Jack (Female) ..................................................................................... ........... ............ 1
2 254841 SCREW- Jack (Male) ... .............................. ..................... ..................................... .. ..................... 1
3 253390 P6011 - 6 Circuit, to Machine Encoder ............................... ........................................................ 1
4 253384 P6015 - 2 Circuit, to Delivery Full Switch ................................. ................ ................................... 1
5 250586 P6008- 3 Circuit, to Powder Spray Assembly/Paper Out ..................................... ..................... 1
6 254445 P6012- 4 Circuit, to Blanket Sensor ....................................... ............................ .. ..................... 1
7 253384 P6018- 2 Circuit, to Air Pressure Sensor ............................... ............... .................................... 1
8 253388 P6007- 4 Circuit, to Paper Transfer Sensor ......... ......................... ...................... ....................... 1
9 253388 P6016 - 4 Circuit, to Feed Table Encoder ..................................... ............................................. 1
10 253394 P6010 · 12 Circuit, to Paper Height and Doubles Sensors ...................................................... 1
11 253388 P6019- 4 Circuit, to Delivery Pile Sensor .................................................................................. 1
12 S25 - to Oil Pressure Sensor ........................................................ ...................... ....................... 1
13 250077 TIE WRAP - Black .................................................................................................... ....... AS REQUIRED
14 254472 CLAMP- Cable, 5/8" Dia.......................................................................................... ....... AS REQUIRED
15 197416 RIVET - Snap ........................................................................... .............. ........................................ 15
16 254530 MOUNTING STRAP- Universal ..................................................................................................... 6
17 179637 ENCODER ASSEMBLY ..... ............................. ...................... ........................ ............ .. ..................... 1

ELECTRICAL

ELECTRICAL
HARNESS- GUARD SWITCHES (OS)
Index Part
1 186989 HARNESS - Guard Switches .......................................................................................................... 1

2 254406 TERMINALS- Tower 2- Ink; S21 ......................................................................... ....................... 2
3 254406 TERMINALS - Tower 2 - Plate /Blanket; S22 ................................... ............................................ 2
4 254406 TERMINALS- Tower 1- Ink Roller; S19 ..................................................... ......... ....................... 2
5 254406 TERMINALS- Tower 1 - Ink; S23 ............ ..... ......... ..... ..... ........... ................................................. 2
6 254406 TERMINALS - Tower 1 - Plate/Blanket; S24 ......................... ....................................................... 2
7 253388 CONNECTOR - 4 C ircuit, P6024 .. ..... ......... ........... ..... ..... ...... ..... .............. ................................... 1
8 172542 CONNECTOR- 34 C ircuit, P9113 ................................... .... ......... .............................................. 1
9 254406 TERMINALS- Tower 2- Ink Roller; S17 .............................................................. .. ..................... 2
9 172547 SHIELD ................. .................................................................... ............................. ..................... 1
10 254839 SCREW - Jack, Male ........................ ...... .... .. ........ ...................................................... ................ 2
11 250077 TIE WRAP .................................................................................................... ................... AS REQUIRED
12 254530 MOUNTING STRAP - Universal ....... ..... ................ ............... ..... ...................................................... 2
13 197416 RIVET - Snap .................................................. ................................................................ AS REQUIRED
14 254472 CLAMP - Cable, 5/8" Dia............................ ..... ..... ..... ........... ..... .... ..... ............... ....... .. ..... AS REQUIRED

ELECTRICAL

ELECTRICAL
HARNESS - GUARD SWITCHES (NOS)
Index Part
1 186989 HARNESSASSEMBLY ... ............... ............... .... .............................................................................. 1

2 172542 CONNECTOR - 34 Circuit, P9113 ... ...... .............................. ..... ............... ............ ....................... 1
3 172547 SHIELD .............................. ......... ..... ........... ................... .................... ......................................... 1
4 254839 SCREW- Jack, Male ............................................ ............................................... ....................... 1
5 254406 TERMINALS- Delivery; S16 ...... .............. .............. ..... ...... .............. .................... ......................... 2
6 254406 TERMINALS - Impression; S18 ....................................... ............................................................ 2
7 250077 STA-STRAP ....................... ................... ............... .......... .............. ................ ............ .. ..... AS REQUIRED
8 254530 MOUNTING STRAP - Universal .......................................................... ..................... ........ ............... 2
9 197416 RIVET- Snap ...... .... .......... .................... .......... .. ................. .................... ........................................ . 2

ELECTRICAL
6, 7, 9 ---1

ELECTRICAL
3500 POWDER SPRAY CHAIN DELIVERY HARNESS
Index Part
1 172985*** HARNESS - Powder Spray Chain Delivery ... oo ..... •oo··· ....... oo. oo ... oo•· .... oo oo ... oo ..... ... oo .. oooo···· ........ 1
0000 • • • •
2 253287 P6049 - Connector, 2 Circuit ........................................................ ··oo······· ................... ·oo········· ..•. 1

3 253387 P6034 - Connector, 4 Circuit ....................................................................................................... 1
4 250586 P6048 - Connector, 3 Circuit ..................... oo···· .... 1
00 • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • •••••• •• ••• ••• • •
5 250920 L28-1, L28-2 - to Powder Spray Solenoid Terminal 0/F oo ... •..... ............... oo .. ....................... 2
00 • • 00 .
6 CLAMP ............................................................................................................................................ 3
7 102124 CAPSCREW - Button Head. oo .. oo ............ .............. ·oo··· .......... oo .......•.... ·oo··· .......... oo ............................ 2
8 001812 NUT- Hex ........................................................ ................... ........... .... ............................................. 2
9 102355 SCREW - Black Oxide, 10-32 x 9/16". oo oooo···oo····oo· oo··--····oo•oooooooooo ........................... oo······· oo············oo 1
10 250077 STA-STRAP ·············· ···········oo···············oo·········· ····oo·oo·········oo···oo········oooooo········· oo-·oo········ AS REQUIRED
*Contact Airtech
*** For machines equipped with infrared dryer units, refer to Powder Spray Assembly in CHain Delivery Section of Parts
Catalog.

ELECTRICAL
1
------------------~A-------------------
(0
'
21 \

ELECTRICAL
VDE LINE FILTER ASSEMBLY
Index Part
1 174048 FILTER· Line, Century 3500 ................................................................................ ......................... 1

2 174049 FILTEA - Line, Ruby 3500 ............... ...... .......................................................................................... 1
3 250357 CLAMP - Cable ....................... ........................................................................................................ 2
4 001259 SCREW- 10-16 x 1/2" .................................................................................................... ................ 2
5 001589 SCREW- 8-32 X 1/4" ........ ............................................................................ ................................... 2
6 001722 WASHER - Star ............................................... ......................... ...................................................... 2
7 001702 WASHER .............................................................. ..... ...................................................................... 2
8 173632 PLATE - Filter MountUng .................................. ...................... ........................................................... 1
9 111034 SCREW - 8-32 X 3/8" ................................................................................................ ....................... 4
10 150081 NUTS - 8-32 ........... ........................................................................................................... .............. 4
11 254211 STAND-OFF -1/2" ................................................................ ........................................................... 5
12 173296 VDE FILTEA - Jump W ire .............................. ................................................................................. 1
13 254691 STAND-OFF - 2-1 /2" ........................................................ ................................................................ 4
14 400545 LABEL - Shock ............................................... ....................................................... ......................... 1
15 173638 PC Board, Toroid ................................................. .... ........................................ ....... .. ..................... 1
16 186994 CORD - Power, Century 3500 ........................................................................................................ 1
16 186995 CORD- Power, Ruby 3500 ............................................................................................................ 1
17 172002 CAPACITORASSEMBLY ....................................................................... .............. ........................... 2
18 254319 FILTER - Line .................................................................................................................................. 1
19 111015 SCREW .................. .............................................. ..... ..................................................................... . 2
20 173295 WIRE - Jumper ............................................... ........................................................... ..................... 1
21 254694 COVER ................... ......................................... ..... .............. ...... ......... ............... ......... ..................... 1
22 111015 SCREW- 6-32 x 1/4" ................................................. .............................. ........................ ................ 8
23 253915 SWITCH - Power .............. ............................................... ............................. ............ ....................... 1
24 101091 CONNECTOR ........ ........................................................................... ............................................. 1
25 178530 BRACKET - Main Switch .................................. .. ...... .............................. ................... ...... ............... 1
26 2541 70 NUT - Lock ...................................... ......... ........ ........ .................... .............. ........... .... ..... ................ 1
27 254171 0-RI NG ......................................................................................................... ................................... 1
28 254697 CONNECTOR - Century 3500 ....................... ................................................................................ 1
28 254080 CONNECTOR - Ruby 3500 ........................ ..... ............................................ ................................... 1
29 253947 PLUG - 30A, 250V ........... ............................................................................................................. 1
30 187229 DECAL - Ground (For 174049 VDE Assembly Only) ..................................................... ................ 1

ELECTRICAL
I
(
/ -
).
/
/
I
I
I 2
3
I
I
4
8
5

ELECTRICAL
FEEDER WIRING I POWER SWITCH
Index Part
1 172995 HARNESS - Feeder Sensor Interconnect ............ ................................................. ........................ .. 1

2 253384 CONNECTOR- 2 Circuit, P6013, Emitter, Doubles ....................................... ........ ....................... 1
3 253383 CONNECTOR - 2 Circuit, J6014, Receiver, Doubles .................................................................... 1
4 252787 SWITCH ............. .................................................................................................... ... ....................... 1
5 253393 CONNECTOR - 12 Circuit, J601 0 .................................................................................. ................ 1
6 172996 HARNESS - Feed Table Limit Switch ............................................................................................. 1
7 252387 CONNECTOR - 3 Circuit, J6022 ............................................................................... ..................... 1
8 253822 CONTACT - Table Limit Switch .......................................... ........................ ...... ....... .. ..................... 1
9 172997 HARNESS - Bail Bar Solenoid ....................................................................................... ................ 1
10 253287 CONNECTOR - 2 Circuit, J6051 ............................................................................... ..................... 1
11 253375 SOLENOID - Bail Bar ........................................................... .............. ...................... .. ..................... 1
12 253915 SWITCH - On/Off ............................................................................................................................ 1

INDEX

Index
Part Page Part Page Part Page
No. No. No. No. No. No.
000014 8-49 9-1 1,9-13 003586 3-5, 6-39

000024 6-21 001710 5-49, 6-17 003855 6-33, 6-51
000666 3-33, 4-3, 5-49, 6-13, 001721 3-5, 3-41, 6-17 005071 1-15, 3-73, 5-19,
6-35, 6-37, 6-43, 7-29, 7-45 001722 5-33, 10-69 5-31, 6-7, 7-13, 7-15
001046 3-77, 8-5 001726 3-13, 3-15, 3-67, 005607 8-31' 8-33, 8-35, 8-37
001047 3-35, 3-77, 8-53, 9-15 3-69, 6-13, 7-31 005620 8-55
001048 5-27, 6-21 001731 3-67, 3-69, 5-55, 6-9, 006675 8-35
001049 3-27, 3-43, 3-49, 6-13, 6-15, 6-19, 6-31' 6-33, 006801 10-33
6-31 , 8-19, 8-53 6-53, 7-29, 7-31, 7-65, 8-19, 8-55 006936 5-31
001060 5-25, 5-29, 5-31' 001740 7-69, 9-9, 9-11 , 9-13 007076 3-29, 3-31
5-33, 5-49, 6-11 ' 6-39, 6-49, 001744 6-23 007533 6-3
7-47, 8-27, 8-29, 8-35, 8-37, 8-43 001749 8-43 007689 6-25
001064 6-7 001750 6-15, 6-31 012379 8-29
001065 8-55 001755 5-21 ' 8-53 014111 8-55
001070 3-7, 3-17, 3-19, 3-67, 001763 5-43, 6-15, 6-31' 014123 5-45
3-69 6-33, 8-27 014151 5-39, 5-49
001073 3-43, 6-5, 6-15, 6-19 001766 5-21 014157 6-9, 6-31
001075 3-41 001771 5-43, 6-33, 8-27, 8-41 014158 3-33, 5-9, 5-11' 5-49,
001076 8-39, 8-45 001772 3-35 6-13, 6-25, 7-21 , 8-29, 9-13
001080 3-37, 3-73, 5-21 ' 001776 8-57 014162 6-53
5-25, 5-49, 6-49, 8-41 001778 1-15, 5-49 014164 8-5
001093 6-5, 7-63 001781 5-41' 5-49 014165 6-25
001094 6-7, 6-9, 6-29, 6-33, 001784 8-45 014170 6-37, 9-9
7-15, 7-19, 8-41 , 8-45 001786 3-37, 8-55 014175 6-43
001095 5-31' 6-31' 8-29, 001804 6-51 014183 1-9, 1-11
8-37, 8-49 001805 7-57, 8-51 014187 6-31' 8-19
001 106 6-27, 7-45 001812 1-9, 4-3, 5-51 ' 6-5, 014190 8-5
001220 8-33, 10-51 8-19, 10-67 014195 5-21 , 7-7, 7-1 1, 7-13,
001234 5-31 001818 6-29, 7-15, 7-41 7-15, 7-19, 7-63
001259 10-69 001832 6-9 014209 1-9, 1-1 1
001260 8-35, 8-39 001833 1-15, 6-25, 7-69, 9-9 014219 5-3, 7-7, 7-9, 7-13,
001279 10-9 001834 3-27, 5-21' 5-49 7-15, 7-39, 7-41, 7-45, 7-49, 7-63
001425 3-83 001837 10-33 014247 5-33
001432 8-53 001840 6-17, 8-35, 8-39 014248 6-5
001523 7-5 001842 6-31' 6-53 014249 7-17, 9-3
001526 3-41 001845 5-49, 8-27 014250 9-3
001568 1-5 001920 8-53 014288 8-19
001575 1-9, 1-11 001936 3-43, 6-5, 6-15 014291 10-31
001589 8-41' 10-69 001956 8-39 014295 1-7, 10-33
001640 7-69, 8-19, 9-9 001978 5-13 014304 3-13, 3-15
001649 1-7, 1-11 , 4-3, 10-25 001980 5-43 014326 6-51
001650 8-5, 8-41 001981 8-53 014327 6-13
001667 1-9 001986 8-47 014353 1-9, 1-13
001677 1-13 001991 7-41 014372 5-19, 6-17
001681 1-3, 10-5 001992 6-17 014381 5-45
001683 6-17, 10-27, 10-31 003042 2-3 014386 5-33, 5-43
001688 8-55 003164 7-19 014459 6-39
001690 3-25 003268 7-47 014461 8-53
001693 10-17 003560 6-17 014464 3-21 ' 3-23, 6-41
001702 4·-3, 10-69 003578 3-67, 3-69, 5-25, 014472 5-27
001706 3-25, 8-29, 8-33, 5-29, 6-53, 7-33, 7-51' 7-59 014504 6-11 ' 6-17' 8-5

Index
014507 8-29 017462 5-5, 5-9, 5-11 , 5-15 073325 6-49

014510 3-27, 6-15 017583 8-47 073385 6-25
014513 8-45 017595 2-3, 6-7 073394 6-25
014515 3-73, 6-11 ' 6-31 ' 017713 2-3 073467 6-25
6-49, 7-41, 8-53 017715 2-3 074399 1-15, 8-33
014520 8-41 ' 8-53 018684 5-25 074724 5-49
014550 7-51 019238 5-5, 5-7 075443 8-47
014562 7-41 019627 9-15 077837 8-53
014576 3-41 ' 5-1 5 020379 6-53 079764 6-17, 6-51
014618 5-13 020444 7-51 080099 3-27
014697 7-45 021013 1-9, 1-13 080312 6-35, 6-37, 6-43
014703 5-49, 6-29 021150 6-11 080564 8-5
014712 8-41 ' 8-55 021203 3-25, 3-43, 4-7, 5-31' 080578 7-47
014713 6-41 ' 6-45 6-17, 6-31 , 8-35 081107 8-35, 8-39
014718 3-41 021208 6-29 081321 5-33
014741 3-43, 5-21 ' 5-31 021861 1-15, 6-13, 6-35, 6- 081515 7-53, 8-27
014761 3-7, 8-45 37, 6-51 ' 7-45 081516 7-53, 8-27
014774 10-39 022621 8-35 081527 8-35, 8-39
014784 5-21, 5-43, 6-3, 7-61 022654 3-21 ' 3-23 081528 8-35, 8-39
014788 3-37, 5-19, 6-53, 023044 8-35 081567 8-53
7-13, 7 -15 025205 6-7. 7-65, 8-47, 9-15 081609 8-53
014799 5-5, 5-15 032868 6-13 081623 8-45
014807 6-29 032HN-SPN 8-7, 8-9, 8-17, 081764 8-5
014808 5-3, 5-49, 9-11 8-23, 10-23 081 789 5-33
014809 7-53, 8-27 032MS12 8-11 081833 8-53
014812 1-3, 1-5 032MS38P 8-11 081836 8-45
014851 7-47 032MS58 8-9 081879 9-1 5
014909 7-13 039642 2-3, 6-7 083706 10-7
015118 6-37, 6-41 041291 7-47 084283 6-23
015369 5-41 0420HB58 8-17 084473 6-3, 7-63
016060 6-5, 7-63 050621 8-27 087756 8-35
016289 6-49 054409 3-43 094428 6-53
016299 8-57 054437 7-37 094449 6-53
016327 6-5, 7-63 064673 8-27 1100115 6-51' 8-21
016389 8-27 065361 6-27' 6-39, 6-41 ' 1100119 6-3, 7-63
016397 8-45 6-47, 7-45 1100130 5-33, 5-51
016398 8-39, 8-45 065402 5-21 1100137 5-49, 5-51 , 6-11 , 8-35
016399 8-27 065833 1-15, 8-35, 8-37, 8-39 100138 6-11
016405 8-27 071181 5-7 100185 3-55, 3-57, 3-59,
016415 8-53 072024 6-5 3-61' 3-63, 3-65, 3-67, 3-69
016430 8-57 072036 6-53 1100204 8-21
016431 8-57 072037 6-5 100228 9-3
016441 8-39 072041 6-5 100334 5-49
016449 8-27 072064 6-3 1100339 5-51 ' 6-19, 6-35, 6-43
016452 8-41 072258 1-15 1100345 5-31' 6-5
016456 8-37 072292 6-25, 6-37 100347 5-49
016470 8-37 072304 5-49, 6-27 100352 5-5
016471 8-37 072411 5-7 1100392 5-39
016572 6-37 072599 6-5 1100490 5-49, 5-51
016574 2-3, 8-47 072822 7-69, 9-9 100529 6-11
016933 2-3, 8-47 073078 5-7 100546 3-33, 7-41 , 7-49

Index
100554 5-17, 6-39 101676 6-21, 7-19 102220 6-15

100576 3-77 101743 1-7, 5-5 102228 3-13, 3-15, 3-67, 3-69
100609 8-55 101756 3-85, 5-5, 5-35, 5-53, 102232 5-31
100622 6-53 7-63, 7-65 102235 5-49
100625 1-3, 1-15, 5-3, 5-43, 101854 5-13 102238 8-55
5-51' 6-25, 7-19, 7-51 101876 6-13, 7-29 102239 5-41
100653 5-45, 6-11 ' 6-15, 101906 5-33 102240 3-83
6-17, 6-33, 6-37, 6-53 101916 8-47 102243 3-13, 3-15, 5-35
100696 7-47 101938 8-29, 8-33, 8-37 102249 8-55
100710 6-39 101943 8-27 102250 8-55
100716 1-5, 1-15, 8-45, 9-5, 101964 3-13 102254 8-55
10-33 101979 1-3 102255 9-15
100731 8-57 101983 10-29 102256 5-17, 5-45
100740 6-39 101995 3-81 102261 8-45
100744 1-15 101999 6-1 3 102266 3-73
100806 5-43, 8-55 102014 8-31' 8-33 102267 6-33
100813 5-51 102019 5-35 102268 6-9
100858 8-29 102036 3-83 102280 9-7
100871 1-3, 8-27 102040 5-25, 5-29, 5-45, 102290 5-37
100878 7-55, 7-57 5-47, 5-51 ' 7-5, 7-19, 7-25, 7-41 102291 5-37
100890 3-27, 5-45, 5-47 102049 5-25, 5-29 102292 3-21' 3-23
100891 3-39, 5-43, 5-45' 102055 5-25, 5-29, 5-49 102300 5-19, 5-43, 7-59
5-47, 7-15, 7-19, 7-49, 7-51 , 102064 3-83, 5-5, 5-25, 5-51 ' 102301 1-3, 1-5
7-61 , 7-65 7-59, 7-61 102302 5-45
100969 8-41 ' 8-57 102066 5-51 102303 1-13, 3-25, 3-37,
100998 6-17 102073 5-45, 5-47 3-79, 4-5, 5-19, 5-35, 5-43,
101 023 8-41' 8-43 102108 3-75 5-45, 8-19, 9-13, 10-3
101031 6-47, 7-31 ' 7-41 10212.2 6-31 102304 5-43
101033 7-19 102124 1-9, 10-67 102306 9-17
101051 5-21' 8-21 102128 5-49 102307 7-41
101086 5-49, 6-53 102129 6-35, 6-43 102309 9-3
101091 7-29, 10-69 102130 6-15 102310 3-43
101093 5-31 102136 5-41 102313 3-29, 5-21 ' 5-31
101144 1-7, 1-11 102142 5-45 102318 7-29, 8-29
101193 7-19, 8-31 , 10-17 102143 5-41 102322 6-7, 6-33, 9-1 7
101 197 5-31 ' 10-25 102144 5-41 102323 6-25
101281 5-25, 7-15, 8-49 102157 1-7, 1-9, 1-11, 1-13, 102325 6-19
101299 5-3 1-15, 3-87, 5-5, 5-7, 5-15, 102332 3-33, 8-35, 8-51 ' 8-
101333 3-87 5-31, 7-31 , 8-19 53, 8-57
101374 9-17, 10-15 102163 6-15, 6-29 102334 8-29, 8-33, 8-37
101395 7-5 102165 1-7, 1-9, 1-11 102336 6-51
101440 9-17 102166 6-15 102337 7-69, 9-9
101441 9-17 102173 3-67, 3-69, 5-39 102340 8-47
101483 3-39, 3-77, 5-31' 102175 8-31 102341 3-75
6-37, 7-55, 7-57 102184 6-13, 7-29 102342 8-35
101499 5-31 ' 5-49 102186 6-21 102345 6-35, 6-37, 6-43,
101537 S.-19, 9-1 7 102191 9-5, 10-3 6-49, 6-51 ' 7-45, 7-47
101548 1-11 102210 9-5 102348 1-15, 8-51
101612 6-23 102215 5-21 102350 6-39, 8-29, 8-43
101626 1-5, 1-15, 6-9, 6-13, 102216 5-27, 5-41, 5-43 102351 6-39
6-19, 6-49, 6-51 , 6-53 102.219 8-27 102354 6-15

Index
102355 8-19, 10-67 102463 3-83 1102545 4-5

102356 1-15,7-21 , 8-29 102464 3-83 1102546 3-67, 3-69
102357 3-13, 3-15, 8-29, 102465 3-29, 3-31 , 3-49 1102549 7-33, 7-59
8-45, 8 -49 102466 7-41 1102553 7-27, 7-65, 7-67
102358 6-25 102467 7-11, 7-15, 7-41 1102555 7-33, 7-51
102359 6-19 102468 7-39 102557 7-9, 7-49
102370 6-49 102469 7-39 102562 7-19
102371 6-17 102474 9-19 1102565 7-7
102372 6-31 102481 7-69, 9-9 1102566 3-85, 5-51, 5-53
102373 6-49 102482 7-69, 9-9 102568 3-81 , 5-11 , 5-17
102374 6-9, 6-19, 6-27, 6-33 102486 3-5, 8-19, 9-13 102569 3-29, 7-63
102380 1-15, 6-49, 8-35 102487 7-69 1102570 6-3, 7-61 , 9-9, 9-13
102381 7-43, 8-29 102491 9-19 1102571 5-21
102383 9-3 102492 7-19 1102572 4-7, 7-13, 7-15, 8-19,
102385 6-49 102493 6-53, 7-13, 7-15 9-13
102386 6-39, 6-49 102494 7-17 102574 5-19
102387 7-43 102495 7-17 102578 3-13, 3-15
102390 6-47 102496 7-19 1102581 3-85, 5-19, 5-53
102391 6-23 102502 3-29 1102582 6-7
102392 6-23 102503 7-51 , 7-63 102585 3-67, 3-69
102394 7-37 102505 3-7 102586 3-7, 3-13, 3-31' 3-67,
102403 7-65, 9-17 102506 7-11 3-69, 3-71
102404 7-69 102508 3-83 1102587 3-15, 3-29
102405 3-71, 3-73, 3-79, 102511 5-33, 7-15 102588 3-21 ' 3-23
5-21 ' 7-35, 7-43, 7-57, 9-3, 9-5, 102512 7-5 102600 7-63
9-11 ' 9-15, 10-3 102514 7-13 1102602 7-63
102410 5-39, 6-7 102515 7-7 1102603 7-65
102418 3-21 ' 3-23, 3-33, 102516 7-15 106108 3-73
3-41 , 5-55, 7-7, 7-27, 7-29, 102517 7-13 10FW 8-9
7-31 , 7 -41, 7-45, 7-65 102518 7-13 110LWT 8-9, 8-11
102419 3-5, 3-25 102519 7-15 1110002 6-11
102420 3-7 102520 7-7 110057 9-17
102421 7-69, 9-9 102521 7-11 110113 7-19
102422 7-69, 9-9 102522 7-15 1111015 10-69
102423 7-69, 9-9 102523 7-41 1111034 8-53, 10-69
102425 3-21 , 3-23, 3-29 102524 7-7 1111052 3-87, 8-21' 8-39
102426 3-21 ' 3-23 102525 7-13 1111053 8-21
102428 3-7, 3-17, 3-19, 3-67, 102526 7-69, 9-9, 9-11, 9-13 111054 6-5, 6- 15, 8-19
3-69 102527 7-5, 7-13 111055 8-53
102430 3-37 102529 7-51 1111056 1-13
102433 3-41 102531 1-15 1111062 5-27
102435 3-87 102533 5-17 1111073 8-27
102440 5-27 102534 9-19 1111074 5-49
102441 3-83, 7-7, 8-29 102535 7-43 1111075 8-55
102452 5-41 102537 5-27 1112521 8-41
102453 5-41 102538 3-39, 7-65, 8-43 112533 5-31
102454 5-25, 5-29 102539 5-13 112652 6-5, 7-19
102457 7-7, 7-9, 7-49 102540 3-55, 3-57' 3-59, 1112C 8-25
102460 7-9, 7-49 3-61 ' 3-63, 3-65 1130033 5-7, 5-15
102461 7-11 ' 7-39, 7-51 102541 3-13, 3-15 141573 8-57
102462 5-35 102543 3-41 1 4238-FL 8-7

Index
14ECT38 8-17 172220 6-17 172517 5-43

14LW 8-17 172223 5-37 172526 6-35
14T38 8-17, 8-23, 10-23 172.2 29 6-15 172539 6-17
150050 6-11 172230 6-47 172542 10-47, 10-55, 10-63,
150081 8-31, 9-17, 10-69 172236 6-27, 7-45 10-65
150083 1-9, 1-11 , 1-13, 1-15, 172237 6-27, 7-45 172543 10-45
3-29, 3-43, 6-13, 6-37, 6-41 , 172239 6-37 172547 10-47, 10-55, 10-63,
6-45, 7-15, 7-47, 8-19, 8-29, 172240 6-39 10-65
8-33, 8-35, 8-37, 8-39 172241 6-37 172548 10-45
150084 1-13, 3-25, 3-31 , 172244 6-37 172549 5-27
3-41 , 3-43, 4-5, 4-7, 5-21 , 6-49, 172245 6-37 172555 9-9, 10-49
7-69, 8-19, 9-9, 9-13 172246 6-17 172560 10-49
150085 3-29, 6-15, 6-29, 6- 172262 6-7 172564 10-17
37, 7-11, 7 -41, 9-5 172263 6-7 172569 10-27
150086 5-21 , 6-3, 6-7, 6-15, 172266 6-41, 6-45 172570 10-27
7-69, 9-9, 9-13 172269 6-41 172598 5-41
150087 3-17, 3-19 172273 5-49 172600 5-41
150088 3-71, 3-79, 5-19, 172274 5-49 172617 6-47
6-39, 9-13 172277 9-13 172619 6-37
167838GA 8-17 172286 8-27 172620 6-7
172002 10-69 172287 8-27 172621 6-7
172060 8-5 172292 8-51 172630 2-3
172061 8-5 172302 8-5 172632 8-51
172075 7-29 172303 8-27 172634 8-19, 9-13
172111 6-45 172304 8-27 172649 8-27
1721 14 6-41 172310 8-33, 8-51 172665 10-39
172117 6-41 172329 6-23 172680 10-39
1721 19 6-51 172337 5-49 172704 4-3
172120 6-41 172352 7-45 172705 4-3
172123 6-17 172354 6-15 172706 4-3
172131 6-35, 6-43 172355 6-15 172707 5-27
172132 6-35 172356 6-7 172711 5-23, 5-27
172133 6-43 172357 6-15 172713 4-3, 5-23, 5-27, 7-67,
172135 6-51 172358 6-15 9-7
172139 6-43 172367 6-51 172717 8-21
172145 6-9, 6-43 172399 5-37 172720 6-27
172146 6-51 172402 5-35 172731 5-37
172147 6-51 172403 3-13, 3-15, 5-35, 5-43 172732 5-37
172148 6-31 172404 5-35, 5-43, 5-45, 5-47 172736 6-17
172149 6-9, 6-43 172437 5-37 172737 6-17
172171 7-11 172438 5-37 172740 8-55
172174 6-9 172447 3-3, 3-45 172742 8-5
172202 6-17 172455 10-13 172744 8-5
172203 6-17 172475 9-5 172745 8-5
172204 6-17 172484 7-69, 9-9 172753 8-55
172207 6-17 172485 7-69, 9-9 172755 8-55
172208 6-17 172496 6-35 172756 8-55
172209 6-17 172498 9-11 172758 8-55
172210 6-15 172499 9-11 , 10-41 172766 8-45
172215 6-41 172513 6-17 172769 8-45
172216 6-41 172516 5-43 172773 8-3

Index
172778 6-9 173104 6-25 1173441 9-3

172802 6-7 173106 6-25 1173442 6-5
172804 6-7 173107 6-9 1173446 6-29
17281 1 1-15, 8-33 173126 5-33 1173447 6-29
172812 6-13, 7-31 173127 1-7 1173448 6-29
172867 6-33 173130 6-15 173454 6-33
172870 5-49 173132 6-43 173456 6-31
172875 10-27 173150 1-9, 1-13 1173457 6-9
172893 8-35 173158 5-37 1173461 6-49
172898 6-49 173173 4-5, 4-7 173488 9-13, 10-13
172900 6-25 173197 6-53 173489 10-21
172908 1-7 173210 2-3 1173490 10-9
172919 6-51 173211 9-15 1173492 10-9
172920 6-51 173219 5-41 1173495 10-9
172921 6-31 173245 8-19 1173496 9-15
172941 1-9 173248 8-31 , 8-53 173500 10-9
172947 3-13, 3-15, 5-35 173249 8-19 173501 10-27
172948 5-49 173250 8-19, 8-21 1173502 10-33
172967 6-15 173251 8-19 1173506 1-13
172968 6-39 173252 8-19 1173507 6-23
172969 3-33 173256 8-19 1173509 6-5
172970 5-33 173259 8-19, 8-25, 9-13 1173511 6-5
172985 8-19, 10-67 173295 10-69 1173514 6-5
172988 5-49, 5-51 173296 10-69 173515 6-5
172995 6-49, 10-71 173303 6-7 173525 8-3
172996 6-49, 10-71 173309 5-49 1173529 8-3
172997 6-49, 10-71 173312 5-49 1173530 8-3
173032 1-15 173322 5-27 173602 9-17
173033 5-45 173350 6-27 173632 10-69
173043 1-7 173357 8-5 1173638 10-69
173044 1-11 173365 3-33 1173645 8-55
173052 5-49 173368 6-15 173649 5-49
173054 1-11 173370 5-35 173659 5-43
173061 1-9 173371 5-35 1173661 8-55
173062 1-11 173395 9-7 1173662 6-53
173066 1-13 173397 6-7 1173663 6-53
173069 1-9 173400 5-37 1173666 5-39
173071 1-9 173415 10-11 , 10-15 173667 5-39
173072 1-13 173416 10-31 173668 8-55
173073 1-9 173418 10-13, 10-15 1173674 6-29
173074 1-13 173425 9-3 1173715 5-43
173075 1-9, 1-13 173427 9-3 1173716 6-17, 7-45
173076 4-3 173428 9-3 1173726 5-45
173077 1-13 173429 9-3 1173727 5-43
173078 1-11 173430 9-3 1173728 5-43
173079 1-9 173431 9-3 173729 5-43
173080 1-13 173432 9-3 173730 5-43
173081 1-9, 1-11 173434 6-5 1173731 5-45
173082 1-9, 1-11 173436 6-5 1173732 5-45
173083 1-9, 1-13, 4-3 173438 6-5 173734 5-43
173093 8-21 173439 6-5 173735 5-43

Index
173736 5-45 174206 1-3 178730 6-11

173737 5-45 174207 1-7 178731 6-11
173738 5-47 174366 8-23 178737 6-37
173739 5-45, 5-47 174367 8-23 178738 6-37
173743 5-45, 5-47 174368 8-23 178741 5-49
173744 5-43, 5-47 174374 8-19 178746 6-37
173745 5-43, 5-47 174430 3-9 178761 6-37
173746 5-43, 5-47 178179 9-3 178763 6-37
173748 5-47 178184 5-27 178764 6-37
173750 5-43 178186 5-3 178765 6-37
173752 8-41 178259 9-3 178766 6-37
173755 5-45, 5-47 178283 1-3 178767 6-37
173756 5-45 178317 10-31 178775 6-13, 7-31
173759 5-43 178318 10-31 178801 6-9
173779 9-15 178319 10-31 178805 6-9
173780 10-9 178341 6-23, 6-25 178806 3-5, 6-9, 6-35
173782 10-19, 10-21 178360 5-25, 5-29 178809 6-33
173784 10-19, 10-21 178366 10-17 178812 6-33
173786 10-33 178400 7-67, 9-7 178813 6-33
173792 10-21 178401 4-3, 5-23, 5-27 178814 6-33
173793 10-21 178402 6-9 178816 6-33
173794 10-21 178403 6-15, 7-67, 9-7 178827 5-43
173795 10-9 178404 4-5, 4-7 178830 5-43
173796 10-5 178407 6-13, 7-29 178835 6-31
173797 10-7, 10-9 178416 5-41 178841 6-29
173802 5-45 178418 6-31 178847 6-31
173810 5-19, 5-43 178420 6-31 178881 6-15, 6-31
173816 5-45 178449 6-9 178901 6-49
173821 5-43 178450 6-9 178903 6-49
173832 8-53 178495 5-43 178904 6-49
173835 8-41 178527 5-41 178906 6-49
173943 5-37 178528 5-41 178907 6-49
174017 5-19 178530 10-69 178908 6-49
174048 10-69 178572 5-41 178917 6-39
174049 7-29, 10-69 178603 6-15 178920 6-39
174074 9-19 178607 6-15 178921 6-39
174149 8-19 178627 6-25 178927 6-39
174152 10-27 178628 6-25 178932 6-15, 6-31
174158 10-29 178629 6-25 178965 6-47
174160 10-31 178634 6-25 178982 6-31
174185 1-9, 1-11, 1-13 178650 5-31 178993 10-3
174188 1-7, 7-3 178654 5-49 178995 5-11
174191 10-23 178670 6-19 179151 5-35
174192 1-11' 7-3 178676 6-19 179156 5-17
174193 1-7 178678 6-19 179166 5-17
174194 1-7 178682 6-33 179167 5-11
174196 1-7 178720 6-15 179171 5-35
174197 1-7 178721 6-27 179172 5-7
174198 1-11 178722 6-35 179232 6-41' 6-45
174199 1-7 178723 6-9, 6-43 179234 6-45
174205 1-15 178728 6-11 179323 5-25, 5-29

Index
179370 3-27, 5-25, 5-29 180531 6-39 1180794 6-19

179417 5-33 180532 6-49 1180824 5-33
179452 5-33 180534 6-39 1180830 6-23
179457 5-49 180537 6-39 1180831 6-23
179470 5-33 180538 6-39 1180832 6-23
179480 5-33 180539 6-39 180835 6-13
179482 5-33 180548 6-3 180840 6-19
179504 5-39 180581 5-37 1180842 6-25
179553 5-51 180588 1-3 1180849 6-53
179573 2-3 180589 1-3 180858 3-87
179575 8-47 180598 6-53 180870 1-3
179618 10-27 180606 6-53 1180881 5-37
179637 8-55, 10-61 180607 6-53 1180882 7-67, 9-7
179666 6-41 180609 6-53 1180908 6-21
179697 5-55 180611 6-53 1180910 6-21
179698 5-55 180613 6-21 180933 5-33
179720 5-49 180615 6-53 180936 5-33
179740 9-17 180624 6-53 1180938 5-33
179767 9-17 180626 6-21 1180959 6-13, 7-29
179804 4-3, 5-23, 5-27 180627 6-53 180960 6-13
179808 9-17 180628 6-53 1180961 6-13, 7-29, 7-31
179815 3-71, 6-13, 7-29 180635 6-21 1180963 9-5
179832 4-3 180640 6-53 1180980 6-1 1
179961 3-3, 3-43 180644 6-27 180987 6-49
179974 3-33 180646 6-27 186005 3-83
180139 1-15 180653 6-5, 6-23 1186015 3-37
180177 1-3 180662 6-41 1186016 3-41
180208 5-25, 5-29, 5-39 180670 6-5 186017 3-41
180349 5-41 180671 6-5 186023 3-75
180361 5-35 180672 6-23 1186030 3-35
180362 5-35 180673 6-25 1186031 3-35
180384 5-11 180674 6-23 186032 3-35
180385 5-9 180675 6-23 186033 3-33
180422 9-3 180678 6-23 1186034 3-33
180443 6-39 180687 6-17 1186039 3-37
180444 6-39 180688 6-17 1186040 3-75
180463 6-5 180690 6-17 1186045 3-29
180472 1-15, 6-13, 6-39, 180691 6-17 186047 3-29
7-19, 7-29, 7-31, 7-45, 8-19 180708 6-53 186048 3-29
180477 4-7 180771 6-13, 7-31 1186053 3-81
180478 4-7 180772 6-13, 7-29 1186055 3-79
180479 4-7 180773 6-13 186056 3-71 , 3-79
180482 4-5 180774 6-13 1186058 3-71 , 3-79
180492 4-7 180775 6-13, 6-19, 7-29 1186062 3-35
180494 4-5, 4-7 180776 6-13, 7-29 1186063 3-43
180497 4-5, 4-7 180778 6-13, 7-31 186082 3-29
180500 4-7 180780 6-13, 7-5, 7-19, 7-31 186083 3-31
180508 4-7 180782 6-13 1186086 3-3, 3-29
180514 1-15 180783 6-1 3, 7-31 1186088 3-29, 3-31
180529 6-33 180792 6-19 186092 3-29
180530 6-39 180793 6-19 186093 3-5, 3-21

Index
186094 3-5, 3-23 186214 3-5 186356 5-31

186095 3-21 ' 3-23 186216 3-3, 3-49 186358 5-49
186096 3-33 186219 3-49 186359 5-49
186097 3-33 186232 3-3 186368 5-49
186098 2-3, 5-5, 5-9, 5-11 , 5-15 186241 3-29 186373 5-31
186099 2-3, 5-9, 5-11 186243 3-29 186375 5-49
186106 3-73 186252 3-5 186383 5-5, 5-7
186107 3-73 186266 3-37 186384 5-5, 5-7
186109 9-17 186268 2-3 186387 5-5, 5-15
186113 5-35 186274 3-37 186388 5-5, 5-15
186114 5-39 186276 5-21 186393 3-55
1861 15 5-35 186277 5-21 186394 3-57
1861 16 5-35 186278 5-21 186398 3-55
1861 17 5-39 186279 5-21 186399 3-57
186123 5-39 186281 5-21 186404 5-43
186126 3-67, 3-69 186282 5-21 186405 6-51
186128 3-67, 3-69 186283 5-21 186406 5-49
186131 3-3, 3-51 186284 5-21 186408 6-35
186132 6-23 186287 5-21 186409 6-9
186135 3-67 186288 5-19 186412 5-51
186138 3-69 186289 5-19 186413 6-37
186140 3-3, 3-45 186290 5-21 186414 6-37
186141 3-3, 3-47 186293 5-21 186415 6-37
186142 3-55, 3-57, 3-59, 3-61 186295 5-21 186421 1-15
186146 3-11 186298 5-19 186422 1-15
186147 3-81 186299 5-19 186424 1-15
186148 3-81 186302 5-31 186427 10-3
186149 3-13, 3-15 186303 5-51 186431 7-69, 9-9
186151 3-67, 3-69 186304 5-31 186433 4-5, 4-7
186166 3-3, 3-11 186305 5-31 186434 7-69, 9-9
186169 3-21 186306 5-31 186435 7-69, 9-9
186170 3-17 186307 5-31 186436 7-69, 9-9
186171 3-19 186308 5-31 186437 7-69, 9-9
186173 3-3, 3-9 186312 5-31 186438 8-53
186176 5-27 186320 5-31 186439 8-49
186177 5-27 186323 5-31 186440 8-49
186178 5-27 186324 5-31 186441 8-37
186179 5-27 186325 5-49 186444 8-49
186184 3-77 186326 5-49 186447 3-71
186189 3-13 186331 5-49 186448 3-71
186190 3-15 186332 5-51 186449 3-71
186192 3-3, 3-9 186333 5-49 186466 5-51
186194 3-27 186336 5-31 186473 5-49. 7-19
186195 3-27 186338 5-31 186474 5-49, 5-51
186196 3-27 186339 5-31 186487 3-85, 5-53, 7-59
186199 3-13, 3-15 186341 5-31 186488 3-85, 5-53, 7-59
186202 3-5 186350 5-31 186491 1-11
186203 3-25 186352 5-31 186492 1-7
186207 3-87 186353 5-31 186493 1-11
186212 3-87 186354 5-19 186494 1-7
186213 3-87 186355 5-19 186495 1-7, 1-11
1-10 Century 3500 PartsCatalog

Index
186496 1-7, 1-11 186707 3-7 1186826 5-7, 5- 13, 5-15

186510 9-15 186708 3-7 1186828 5-5
186536 8-31 186721 3-17, 3-19, 3-67, 3-69 1186831 5-25
186540 8-47 186722 3-7, 3-17, 3-19, 3-67, 1186832 5-5, 5-7, 5-15
186551 8-27 3-69 1186833 5-5, 5-7, 5-15
186552 8-27 186723 3-31 186834 5-5, 5-7
186560 8-31 186726 3-55, 3-57, 3-59, 186835 5-5, 5-7
186561 8-31 3-61 ' 3-63, 3-65, 3-67, 3-69 1186836 5-25, 5-29
186562 8-35, 8-39 186731 3-27 1186837 5-25
186585 8-45 186733 3-13, 3-15 186838 5-25
186586 8-45 186740 3-77 186839 5-25
186588 8-45 186741 3-77 1186840 5-25
186590 8-29 186744 3-59 1186841 5-25
186591 8-29 186745 3-61 1186842 5-25, 5-29
186593 8-33, 8-37 186746 3-63 1186844 5-5, 5-15
186599 8-39 186747 3-65 186845 5-5, 5-15
186603 8-49 186748 3-3, 3-7 186848 5-29
186604 8-45 186749 3-49 1186866 5-17
186605 8-55 186750 8-41 1186875 1-9
186606 8-47 186751 2-3, 8-47 186876 1-13
186609 8-53 186752 8-41 1186883 1-9
186610 8-49 186753 8-49 1186884 1-13
186613 8-45 186755 8-57 1186892 1-1 3
186614 8-29, 8-33, 8-37 186757 8-33, 8-37 186893 1-13
186615 8-49 186759 8-21 186896 10-25
186616 8-53 186760 8-21 1186900 1-3
186618 8-49 186764 1-9, 8-19 1186901 1-3
186620 8-47, 8-49 186767 8-53 186902 1-3
186622 8-45 186770 8-41 ' 8-53 186903 1-5
186623 8-39, 8-41 186771 8-55 1186904 1-5
186625 3-23 186775 5-35 1186908 1-15
186628 6-53 186777 5-39, 5-41 186909 1-15
186639 3-3, 3-53 186778 5-35 186910 1-5
186640 3-3, 3-53 186779 3-81 1186914 1-3
186641 3-3, 3-53 186780 5-41 1186915 1-3
186652 5-51 186786 5-25 1186916 1-5
186653 5-51 186788 5-21 1186919 1-15
186654 5-5 186789 5-41 186920 1-3, 4-5
186655 5-35 186794 8-29 186921 1-5
186665 5-35 186795 1-15 1186922 1-15
186667 5-35 186796 8-29 1186923 4-5
186668 5-35 186797 8-29 186924 1-3
186669 5-35 186799 5-25, 5-29 1186925 1-5
186670 5-39 186801 5-25, 5-29 1186928 1-5
186671 5-41 186802 5-25 1186929 5-3
186672 3-71 , 3-79 186803 5-25 186930 5-3
186673 3-71, 3-79 186804 5-25, 5-29 186931 5-3
186674 9-11 186805 5-25, 5-29 1186932 5-3
186678 3-21 ' 3-23 186813 5-25, 5-29 1186933 1-3
186703 3-3, 3-31 186814 5-25, 5-29 186936 1-15
186705 3-31 186825 1-7, 5-5 186939 1-15, 8-33

Index
186942 1-5, 5-3 187093 3-33 187248 10-29

186943 1-15 187095 8-29 187249 10-25
186945 3-63, 3-65 187097 8-29 187264 6-51
186947 3-7 187102 3-77 187272 3-39
186957 10-49 187104 3-77 187273 3-39
186963 8-29 187107 3-77 187274 4-5, 4-7
186975 10-7 187108 9-19 187301 4-5
186976 10-7 187112 3-31 187303 3-59, 3-61 , 3-63, 3-65
186979 10-57 187113 7-69, 9-9 187305 3-87
186980 10-7 187116 7-69, 9-9 187306 3-87
186982 10-11 , 10-15 187117 7-69, 9-9 187307 3-87
186984 10-41 187150 5-3 187310 3-3, 3-33, 3-83
186989 10-63, 10-65 187151 5-3 187322 3-27
186990 10-61 187152 5-3 187326 5-31
186991 10-55 187159 3-31 187327 5-31
186992 10-47 187162 4-7 187328 5-31
186993 10-43, 10-45 187163 4-7 187329 5-31
186994 10-69 187166 4-5 187330 5-31
186995 10-69 187167 4-5, 4-7 187340 8-29
186997 10-53 187168 7-41 187347 8-43
186999 10-59 187176 10-39 187352 8-43
187001 10-39 187178 10-39 187357 8-29
187004 10-51 187182 10-33 187359 8-43
187018 10-19 187184 8-23 187360 8-43
187020 10-25 187188 1-15 187374 8-29
187022 10-25, 10-27, 10-29, 187190 10-9 187375 7-63
10-31 187192 10-27 187376 7-63
187023 10-33 187194 10-27 187379 7-63
187027 10-33 187197 10-33 187384 1-15, 8-29
187029 10-33 187198 10-33 187386 8-29
187033 1-15 187200 9-19, 10-37 187388 8-29
187034 10-3 187201 9-19 187389 1-15, 8-29
187035 10-3 187202 10-17 187390 8-29
187041 10-27 187203 10-3, 10-17 187395 8-29
187043 10-27 187204 10-9 187397 8-29
187045 10-27 18721 1 10-29 187398 8-29
187047 10-27 187213 9-13, 10-15 187402 7-59, 7-63
187056 8-41' 8-43 187214 10-13, 10-15 187403 7-59, 7-63
187058 8-41' 8-43 187215 9-19, 10-37 187404 7-59, 7-65
187072 8-43 187216 10-3 187406 7-63
187075 8-29 187217 3-25 187407 7-43, 7-63
187077 8-31' 8-43 1872.21 10-21 187410 7-43, 7-63
187079 8-57 187226 9-19, 10-37 187411 7-55, 7-57
187082 8-29 187228 10-31 187412 7-55, 7-57
187083 10-33 187229 10-69 187413 7-65
187084 1-7 187230 10-21 187414 7-63
187085 8-37 187232 9-11' 9-13 187415 7-63
187087 3-43 187235 6-9 187416 7-63
187088 3-43 187238 8-17 187423 7-63
187089 3-43 187239 8-17 187426 7-65
187090 3-43 187245 7-69 187427 7-51

Index
187430 7-35 187551 7-41 1187646 7-11

187434 7-37, 7-49 187552 7-41 1187649 7-11
187436 7-37 187553 7-41 1187652 7-15
187443 7-33 187554 7-41 1187653 7-11
187444 7-33 187561 7-39 1187655 7-1 5
187445 7-33 187562 7-41 187656 7-15
187447 7-37 187564 7-41 187657 7-11
187450 7-65 187565 7-31 1187658 7-11
187451 7-65 187571 7-45 1187659 7-15
187452 7-25 187572 7-45 187660 7-19
187453 7-23 187573 7-45 187661 7-19
187454 7-25 187574 7-45 1187663 7-1 9
187455 7-25 187575 7-45 1187664 7-7
187457 7-65 187577 7-45 1187671 7-19
187458 7-23, 7-25 187580 7-63 1187672 7-19
187459 7-25 187581 7-63 187673 7-19
187461 7-45 187582 7-45 187675 7-19
187463 7-51 187583 7-45 1187676 7-19
187467 7-51 187600 7-7 1187677 7-19
187468 7-37 187603 7-7 187678 7-19
187469 7-37 187604 7-7 1187683 7-19
187472 7-33, 7-37 187605 7-5 1187684 7-19
187479 7-29 187606 7-19 1187685 7-1 7
187483 7-51 187607 7-7 187686 7-17
187487 7-51 187608 7-7 187687 7-17
187491 7-61 187609 7-7 1187689 7-17
187493 7-61 187610 7-23 1187691 7-1 9
187494 7-53 187611 7-13, 7-19 187693 7-21
187496 7-61 187612 7-5, 7-7, 7-13, 7-15, 187694 7-21
187499 9-3 7-19 1187695 7-21
18751 1 7-7, 7-9 187615 7-5 1187707 7-3
187513 7-9, 7-49 187616 7-23 187715 7-3
187514 7-9, 7-49 187617 7-15, 7-23 187731 7-29
187515 7-49 187618 7-23 1187732 7-27
187516 7-9 187619 7-23 1187734 7-27, 7-29
187518 7-41 187620 7-13 1187735 7-65
187521 7-49 187622 7-13, 7-1 5 1187746 7-31
187523 7-49 187623 7-13 187748 7-31
187524 7-49 187625 7-13 187749 7-31
187525 7-49 187626 7-13 1187750 7-35
187526 7-41 187627 7-13 1187751 7-35
187527 7-41 187628 7-13, 7-15 187754 7-51
187529 7-41 187630 7-13 1187755 7-51
187530 7-49 187632 7-11 1187757 7-65
187534 7-49 187633 7-11 1187758 7-57
187535 7-49 187634 7-11 187759 7-43
187538 7-49 187635 7-11 187760 7-43
187539 7-49 187636 7-13 1187761 7-43
187541 7-39 187642 7-19 1187762 7-43
187544 7-41 187643 7-15 187763 7-7
187547 7-39 187645 7-15 187764 7-7

Index
187765 7-7 190712 7-41 196901 6-31

187766 7-7 190713 3-73, 6-31' 6-49, 196906 2-3
187767 7-7 7-41' 8-53 196909 5-51
187768 7-7 190731 1-3, 6-49 196945 5-25
187769 7-43 191215 5-25 196955 8-55
187779 7-35, 7-45 191384 3-71 , 3-79, 6-7, 6-9, 196971 4-3, 5-23, 5-27, 7-21
187782 7-19, 7-45 6-35, 6-43, 6-53 196973 9-17
187783 7-31 191786 8-39, 8-41 196977 5-27
187785 7-23 191797 1-15, 6-33, 6-53, 8- 196978 5-27
187786 7-45 19, 8-33, 9-13 196980 9-11
187791 7-37 192034 6-11 196988 8-31
187800 7-45 192035 6-11' 7-45 196992 5-49
187801 7-47 192125 6-43 196997 3-43, 3-75, 6-5
187806 7-47 192182 6-49 197000 6-45
187808 7-47 192204 3-73 197001 5-33, 6-29, 6-49
187811 7-47 192206 3-73 197009 6-7
187813 7-47 192209 8-33, 8-35, 8-37, 8-39 197011 6-17
187814 7-47 192258 6-17 197024 5-7
187816 7-47 192795 6-11 197025 5-7
187818 7-47 192797 6-29 197026 7-41
187819 7-47 192798 5-9 197038 8-37
187820 7-47 193035 6-49 197046 3-7
187828 7-51 193090 5-5, 5-7 197048 3-71 , 3-79, 8-45
187829 7-51 193338 1-9, 1-13, 5-25, 5-29 197052 3-37, 5-49
187830 7-51 193577 6-27, 6-39 197054 6-15
187837 7-69, 9-9 193647 3-41 197055 5-31
187882 7-63 194835 8-27 197076 5-17, 6-33
187898 7-45 195234 5-45 197077 6-19
187899 7-45 195236 3-71 , 3-79, 8-45 197078 6-19
187904 7-65 195259 3-5 197079 5-21
187906 7-31 195401 8-41' 8-43 197080 5-21
187907 7-41 195837 7-7, 7-9, 7-41 , 7-49 197086 6-11
187909 7-19 196330 8-35 197087 6-11' 6-51
187911 7-47 196390 8-27 197088 6-11
187912 7-65 196397 6-7 197106 5-35
187915 7-65 196398 8-53 197118 7-13
187922 7-65 196399 8-57 197126 6-31
187924 7-65 196443 8-41 197127 6-29
187927 7-37 196444 8-41 197130 5-41
187932 7-65 196453 8-37 197132 5-41
187934 7-65 196454 1-15 197134 6-33, 7-49, 7-63
190129 5-43, 5-45, 6-15 196768 8-27 197135 5-41
190130 6-17 196830 5-35 197137 5-41 , 5-45, 5-47
190149 3-41 196832 5-35 197140 6-31
190157 8-45 196834 7-65 197143 6-11
190220 8-45 196849 6-45 197145 6-35, 6-37, 6-43
190254 5-41' 6-33, 6-39 196850 8-55 197147 6-31
190345 6-23 196873 7-7, 7-1 5 197148 6-15
190394 6-9, 6-35 196884 3-55, 3-57, 3-59, 197157 6-17
190631 3-13, 3-15 3-61' 3-63, 3-65 197158 6-17
190646 7-37 196891 6-25 197159 6-17

Index
197160 6-15, 7-39 197422 8-45 1197531 7-19

197166 6-49 197429 7-67, 9-7 1197534 10-7
197168 5-37 197435 7-69, 9-9 1197536 10-7, 10-9
197174 6-33 197440 3-27, 5-27 1197538 7-11
197175 6-49 197441 5-27 1197540 10-7
197178 6-9 197443 3-59, 3-61, 3-63, 3-65 197544 3-77
197180 6-31 197444 3-55, 3-57, 3-59, 197546 3-55, 3-57
197182 6-15, 6-19, 9-17 3-61 , 3-63, 3-65 1197547 7-19
197185 7-53, 8-27 197447 3-49 1197548 7-17
197194 2-3, 6-7 197449 3-49, 7-43 197554 7-15
197195 1-13, 7-49 197451 5-27, 6-15 197555 7-11
197209 3-55, 3-57, 5-37 197452 5-27, 5-41 , 5-43 1197556 7-1 9
197219 6-17 197453 5-47 1197557 7-21
197222 6-53 197454 5-43 1197558 3-81
197293 5-21 197466 3-81 1197559 7-45
197294 3-13, 3-15 197467 5-35, 5-41 197561 3-25
197296 7-69, 9-9 197468 5-39, 5-41 197930 7-65
197297 7-69, 9-9 197469 5-35 1199344 5-39
197306 7-5 197470 5-39, 5-41 200730 10-35
197309 7-21 197471 5-35 202144 9-5
197310 7-21 197473 5-41 202475 9-5, 10-9
197312 4-7 197474 3-37, 7-41 202708 7-67, 9-7
197316 9-3 197475 3-37 21390202 8-9
197326 6-13, 7-29 197476 3-37 233822 1-5
197327 9-7 197479 3-81 2436009 10-23
197329 9-17 197480 3-43 2436010 10-23
197330 9-17 197481 3-81 2446011A 8-17
197331 9-7, 9-17 197483 3-81 250062 10-53
197337 6-19 197485 5-35 250077 4-5, 4-7, 5-27, 7-19,
197338 6-19 197486 5-35 8 -19, 8-21, 9-19, 10-35,
197343 5-25, 5-29, 5-39 197488 5-39 110-39, 10-43, 10-45, 10-47,
197344 5-25, 5-29 197489 5-39 10-51, 10-53, 10-55, 10-57.
197345 6-11 197492 5-41 10-59, 10-61 , 10-63, 10-65, 10-67
197350 9-9 197493 5-39 250098 4-3, 10-7, 10-31
197353 5-21 197494 5-29 250203 6-49
197354 5-21 197495 5-41 250205 8-51, 9-3
197387 6-13, 7-31 197496 5-25 250206 10-7
197389 5-27 197497 5-35 250306 10-51
197391 9-5 197498 5-5, 5-15 250342 10-53
197394 5-39 197502 5-31 250356 6-51, 8-21, 10-57
197395 4-3, 9-17 197504 5-33, 5-49 250357 10-69
197396 4-3, 9-17 197506 5-23, 5-27 250493 7-41 , 7-65
197397 4-3, 5-23, 5-27 197507 5-23, 5-27 250560 7-47
197407 10-25 197508 5-27 250586 10-61, 10-67
197410 6-37 197510 5-23, 5-27 250920 10-67
197416 4-3, 9-3, 9-15, 10-3, 197511 5-43 250931 10-59
10-39, 10-43, 10-45, 10-47, 197519 7-41 250945 10-43
10-49, 10-55, 10-57. 10-59, 197525 7-17, 7-19, 7-21 251 189 8-1 7
10-61, 10-63, 10-65 197528 7-21 , 7-27 251191 9-3
197420 8-19 197529 7-21 , 7-27 251520 10-17
197421 6-53 197530 7-27 252094 6-25

Index
252387 8-17, 10-71 254157 10-39 254807 10-21

252527 9-3 254160 10-39 254815 9-19
252537 10-21 254161 10-59 254821 10-19
252787 10-71 254162 10-17 254822 10-19
252793 10-35, 10-51 254163 10-17 254823 10-19
253044 10-27 254170 7-29, 10-69 254824 10-11
253277 10-45 254171 7-29, 10-69 254825 10-19
253286 10-43, 10-45, 10-53, 254180 10-25 254826 10-19
10-57 254182 10-27 254828 10-53
253287 10-67, 10-71 254211 1-15, 10-9, 10-69 254829 10-53
253303 10-37 254260 10-59 254830 10-61
253327 10-53 254262 9-3 254831 10-61
253328 10-49 254319 10-69 254833 10-53
253329 10-11 254377 8-51 254836 9-19
253375 6-31 ' 6-49, 8-53, 10-71 254379 10-35 254838 9-19
253381 3-73 254401 10-57 254839 10-63, 10-65
253383 4-3, 9-3, 10-71 254403 10-51 254840 10-55
253384 10-35, 10-47, 10-53, 254406 10-63, 10-65 254841 10-61
10-55, 10-61 ' 10-71 254432 10-9 254842 10-45, 10-61
253386 10-53, 10-57 254433 10-27 254844 9-19
253387 9-3, 10-43, 10-51' 10-67 254445 10-61 254860 10-33
253388 10-13, 10-47, 10-55, 254472 8-19, 10-39, 10-45, 254867 4-7
10-61 , 10-63 10-47, 10-53, 10-55, 10-59, 26390212 8-9, 8-21
253390 10-37, 10-61 10-61' 10-63 26390221 8-9
253392 10-47 254530 7-27, 7-65, 9-15, 2739021A 8-13
253393 10-13, 10-71 10-43, 10-45, 10-47, 10-49, 27490542 8-11
253394 10-45, 10-61 10-53, 10-55, 10-57' 10-61 ' 27790090 8-13
253524 9-3 10-63, 10-65 27790611 8-13
253543 10-21 254531 7-65, 7-67 2839007C 8-17
253655 10-21 254533 10-21 2979021 8-23, 10-23
253721 10-41' 10-57 254534 10-21 31060411 8-7
253729 10-39 254543 10-21 32910381 8-11
253822 1-3, 1-15, 6-49, 7-31, 254687 10-31 32930291 8-11
7-41, 7-57, 10-71 254691 10-69 32930301 8-11
253848 10-57 254694 10-69 33860201 8-7
253860 10-29 254697 10-69 344102A 8-9
253862 10-29 254700 10-25 34510741 8-7
253864 10-29 254701 10-25 36310211 8-9, 8-21
253865 10-29 254702 10-29 36910161 8-13
253866 10-29 254706 10-29 38Panel 10-23
253868 10-29 254707 10-29 38NB916 8-17
253890 10-31 254708 10-29 38PANEL 8-23
253898 10-45 254709 10-29 400545 7-65, 9-15. 10-5,
253905 10-29 254710 10-29 10-21, 10-69
253915 7 -29, 10-69, 10-71 254711 10-29 400757 1-7
253916 9-17 254712 10-29 400900 7-53, 8-27
253918 4-5 254756 7-31 400901 8-27
253932 8-23, 10-29 254765 6-9, 10-29 401232 8-41
253947 10-69 254766 6-9, 7-31, 10-29 401352 5-19
254080 7-29, 10-69 254771 10-33 401733 5-31
254154 10-17 254773 10-33 401734 5-31

Index
402625 8-41 6831503 8-23, 10-23

403400 1-7 6955008 8-23, 10-23
41-440 8-17 6LWT 8-7, 8-11, 8-13
41316001 8-17 6PHSM14 8-9, 8-17
41742006 8-17 6SMTAP38P 8-13
4209905 8-7 700018 7-37
42099098 8-13 700134 7-37
42211001 8-13 700149 7-37
42411051 8-15 78304-9000 8-17
42411054 8-17 8-FR089 8-17
42412015 8-17 8-FR66 8-23, 10-23
42412016 8-17 805-1106 8-9
42415065 8-17 8221402A 8-17
42423040 8-17 832HN-NYL 8-23, 10-.23
42431052 8-17 832MS38 8-15
42556003 10-23 832SHN 8-17
42669012 8-17 84119103 8-17
43324102 8-9 8LWT 8-15
43443905 8-17 8SM12 8-15
43453904 8-23, 10-23 AL-4 8-7, 8-15
43466315 8-25 CH-0407 8-7, 8-9
440HN 8-9 CW-0805 8-7, 8-23, 10-23
440MS34 8-9 FAS170602-24 8-13
47420632 8-17 GSTFILTER 8-25
47623410 8-7 I-14T12R 8-17
480319-10 8-15 IRWL-8LUE 8-7, 8-23
480349-0 8-13 IRWL-81ue 10-23
4LWT 8-9, 8-21 IRWL-RED 8-9
5X442 8-17 IRWL-WHITE 8-7
62030 8-17 LC8-2 8-17
623MS12 8-13 UM5006 8-9
623MS14 8-13 UN5006 8-7
632MS12 8-7, 8-17
632MS14 8-7, 8-11
632SHIN 8-17
65230571 8-7
67312051 8-17
6741201A 8-13
67424081 8-9
67526381 8-7
67554391 8-17
6762105A 10-23
67664111 8-7
6778805A 8-9, 8-21
6785052A 8-17
6785151A 8-17
67853198 8-7
6785554A 8-17
6785555A 8-17
6785568A 8-17
6822308A 8-17

A.B. Dick Company
Worldwide Headquarters
7400Caldwe11Ave.
Niles, Illinois 60714 QIAWlDICK.
(800)-422-3616
(847)-779-1900
(847)-647-6940 Fax
www.abdick.com
03/01/01

A.B Dick 3500 Manual PDF

Uploaded by

Copyright:

Available Formats

A.B Dick 3500 Manual PDF

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

A.B Dick 3500 Manual PDF

Uploaded by

Copyright:

Available Formats

®

© 1996, A.B.Dick Company P/N 177196 (REV.O)

THIS PARTS MANUAL IS INTENDED ONLY TO ASSIST QUALIFIED PERSONS IN

PARTS IDENTIFICATION AND ORDERING INSTRUCTIONS

CRANKS, HANDLES AND KNOBS ................................................................................ 2-1

TOWERS .......................................................................................................................... 3-1

INK FORM SOCKET #3 (OS) ................................................................ ........................................ 3-63

OIL SYSTEM ..................................................................................................................... 4-1

MID SECTION ................................................................................................................... 5-1

STOP FINGER ASSEMBLY AND GUIDE ..................................................................................... 5-49

UNIVERSAL FEEDER ..................................................................................................... 6-1

STREAM FEEDER ........................................................................................................... 7-1

SHEET SEPARATION UNIT- PART 9 ........................................................................................... 7-21

CHAIN DELIVERY ............................................................................................................ 8-1

CHAIN DELIVERY (NOS FRAME)- PART 2 ................................................................................. 8-35

BASE ................................................................................................................................ 9-1

ELECTRICAL ................................................................................................................. 10-1

D.C. POWER CABLE ASSEMBLY- (NOS) . ................. .............................................................. 10-39

INDEX ................................................................................................................................ 1-1

COVERS AND GUARDS

Century 3500 Parts Catalog 1-1

1-2 Century 3500 Parts Catalog

INK AND DAMPENER SAFETY GUARDS

Century 3500 Parts Catalog 1-3

1-4 Century 3500 Parts Catalog

IMPRESSION SAFETY GUARD

Century 3500 Parts Catalog 1-5

1-6 Century 3500 Parts Catalog

OPERATOR SIDE COVERS- PART 1

1 102165 SCREW · Phillips, 10-12 x 1-1/4" ...... .............. ................................................................................. 8

10 173043 COVER -Feeder, Mid ...... .... 1

12 186495 COVER · Mid ..... ....... oo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . .. . . . . . . . . . . . . 1

13 186494 COVER - Tower2 ...... ............. ......................... ...... ............................................................ .... 1 00 . . 00 . . . . .

19 174197 DECAL- Fountain Sweep ................................................................................................................ 2

21 174199 DECAL - Lateral Paper Adjustment .. oo . . . . . . . . 000000 . . 1

22 400757 DECAL- A.B. DICK ...... o o . . oo . . . . . . . . . . . . oo . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . 1

23 174193 DECAL- Lateral Adjustment ....... 2

Century 3500 Parts Catalog 1-7

1-8 Century 3500 Parts Catalog

OPERATOR SIDE COVERS - PART 2

1 173082 NUT · Self Clinching ....................... ................................................................................................ 7

Century 3500 Parts Catalog 1-9

NON-OPERATOR SIDE COVERS- PART 1

Century 3500 Parts Catalog 1-11

1-1 2 Century 3500 Parts Catalog

NON-OPERATOR SIDE COVERS· PART 2

1 150083 NUT· Lock, 10·32 ....................................................................................... ................................... 8

Century 3500 Parts Catalog 1-13

CHAIN DELIVERY I FEED END SAFETY GUARDS

1 186909 GUARD· Tower2 ...... ............................................ ........................................ ..... .... .......................... 1

Century 3500 Parts Catalog 1-15

Century 3500 Parts Catalog 2-1

2-2 Century 3500 Parts Catalog

CRANKS, HANDLES AND KNOBS

1 173210 HANDLE - Ratchet ........... ....... 2

5 039642 RING - Plastic .. 0 0 0 0 . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6 197194 SCREW -Crank ....... 2

8 016574 WASHER - .315 i.d. x .687 o.d ..... .... .... oo . . . . oo . . . . . 1

9 016933 KNOB ................................................ ................................. ............................................ ................. 1