Page 1/8

Safety data sheet

according to 1907/2006/EC, Article 31
Printing date 26.02.2015 Version number 12 Revision: 16.01.2015

SECTION 1: Identification of the substance/mixture and of the company/undertaking

· 1.1 Product identifier
· Trade name: DINITROL PASTA
· 1.2 Relevant identified uses of the substance or mixture and uses advised against
No further relevant information available.
· Application of the substance / the mixture Corrosion inhibitors
· 1.3 Details of the supplier of the safety data sheet
· Manufacturer/Supplier:
DINOL GmbH
Pyrmonter Str. 76
D-32676 Lügde
Tel: +49 5281 9829 80
Fax: +49 5281 9829 860
E-mail: [email protected]
· Further information obtainable from: Research & Development
· 1.4 Emergency telephone number:
Giftnotruf Berlin +49(0)30 30686 790 Beratung in Deutsch und Englisch.

SECTION 2: Hazards identification

· 2.1 Classification of the substance or mixture
· Classification according to Regulation (EC) No 1272/2008

GHS02

Flam. Liq. 3 H226 Flammable liquid and vapour.

· Classification according to Directive 67/548/EEC or Directive 1999/45/EC
R10: Flammable.
· Information concerning particular hazards for human and environment:
The product has to be labelled due to the calculation procedure of the "General Classification guideline for
preparations of the EU" in the latest valid version.
· Classification system:
The classification is according to the latest editions of the EU-lists, and extended by company and literature
data.
· 2.2 Label elements
· Labelling according to Regulation (EC) No 1272/2008
The product is classified and labelled according to the CLP regulation.
· Hazard pictograms

GHS02

· Signal word Warning

· Hazard statements
H226 Flammable liquid and vapour.
· Precautionary statements
P210 Keep away from heat/sparks/open flames/hot surfaces. - No smoking.
P243 Take precautionary measures against static discharge.
P280 Wear protective gloves/protective clothing/eye protection.
P303+P361+P353 IF ON SKIN (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin
with water/shower.
P403+P235 Store in a well-ventilated place. Keep cool.
P501 Dispose of contents/container in accordance with local/regional/national/international
regulations.
(Contd. on page 2)
GB

40.1.0
 Page 2/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 26.02.2015 Version number 12 Revision: 16.01.2015

Trade name: DINITROL PASTA

(Contd. of page 1)
· 2.3 Other hazards
The petroleum naphtha / petroleum distillate / lubricating oil meet the requirements for not being classified as
carcinogenic (<0,1% benzene alt<3% (w/w) DMSO extract (IP 346)).
· Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.

SECTION 3: Composition/information on ingredients

· 3.2 Chemical characterisation: Mixtures
· Description: Mixture of substances listed below with additions.
· Dangerous components:
CAS: 64742-48-9 Naphtha (petroleum), hydrotreated heavy 10-<25%
EC number: 919-857-5 Xn R65
Reg.nr.: 01-2119463258-33 R10-66-67
Flam. Liq. 3, H226; Asp. Tox. 1, H304; STOT SE 3,
H336
· Additional information: For the wording of the listed risk phrases refer to section 16.

SECTION 4: First aid measures

· 4.1 Description of first aid measures
· After skin contact: If skin irritation continues, consult a doctor.
· After eye contact:
Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor.
· 4.2 Most important symptoms and effects, both acute and delayed No further relevant information available.
· 4.3 Indication of any immediate medical attention and special treatment needed
No further relevant information available.

SECTION 5: Firefighting measures

· 5.1 Extinguishing media
· Suitable extinguishing agents: CO2, sand, extinguishing powder. Do not use water.
· For safety reasons unsuitable extinguishing agents:
Water
Water with full jet
· 5.2 Special hazards arising from the substance or mixture No further relevant information available.
· 5.3 Advice for firefighters
· Protective equipment: Mount respiratory protective device.
· Additional information Cool endangered receptacles with water spray.

SECTION 6: Accidental release measures

· 6.1 Personal precautions, protective equipment and emergency procedures
Wear protective equipment. Keep unprotected persons away.
· 6.2 Environmental precautions: Do not allow to enter sewers/ surface or ground water.
· 6.3 Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
Ensure adequate ventilation.
Do not flush with water or aqueous cleansing agents
· 6.4 Reference to other sections
See Section 7 for information on safe handling.
See Section 8 for information on personal protection equipment.
(Contd. on page 3)
GB

40.1.0
 Page 3/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 26.02.2015 Version number 12 Revision: 16.01.2015

Trade name: DINITROL PASTA

(Contd. of page 2)
See Section 13 for disposal information.

SECTION 7: Handling and storage

· 7.1 Precautions for safe handling
Ensure good ventilation/exhaustion at the workplace.
Use only in well ventilated areas.
· Information about fire - and explosion protection:
Keep ignition sources away - Do not smoke.
Protect against electrostatic charges.
· 7.2 Conditions for safe storage, including any incompatibilities
· Storage:
· Requirements to be met by storerooms and receptacles: No special requirements.
· Information about storage in one common storage facility: Not required.
· Further information about storage conditions: Keep container tightly sealed.
· 7.3 Specific end use(s) No further relevant information available.

SECTION 8: Exposure controls/personal protection

· Additional information about design of technical facilities: No further data; see item 7.
· 8.1 Control parameters
· Ingredients with limit values that require monitoring at the workplace:
The product does not contain any relevant quantities of materials with critical values that have to be
monitored at the workplace.
· DNELs
64742-48-9 Naphtha (petroleum), hydrotreated heavy
Oral Long-term - systemic effects, general population 125 mg/kg bw/day (General Population)
Dermal Long-term - systemic effects, general population 125 mg/kg bw/day (General population)
Long-term - systemic effects, worker 208 mg/kg bw/day (Worker)
Inhalative Long-term - systemic effects, worker 871 mg/m3 (Worker)
· Additional information: The lists valid during the making were used as basis.
· 8.2 Exposure controls
· Personal protective equipment:
· General protective and hygienic measures:
Wash hands before breaks and at the end of work.
Do not inhale gases / fumes / aerosols.
· Respiratory protection: Not required.
· Protection of hands: Not required.
· Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on further marks of quality
and varies from manufacturer to manufacturer. As the product is a preparation of several substances, the
resistance of the glove material can not be calculated in advance and has therefore to be checked prior to the
application.
Nitrile rubber
Recommended thickness of the material: ≥ 0.12 mm
· Penetration time of glove material
> 480 min.
The exact break trough time has to be found out by the manufacturer of the protective gloves and has to be
observed.
(Contd. on page 4)
GB

40.1.0
 Page 4/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 26.02.2015 Version number 12 Revision: 16.01.2015

Trade name: DINITROL PASTA

(Contd. of page 3)
· Eye protection:

Tightly sealed goggles

SECTION 9: Physical and chemical properties

· 9.1 Information on basic physical and chemical properties
· General Information
· Appearance:
Form: Pasty
Colour: Red
· Odour: Solvent-like
· Odour threshold: Not determined.
· pH-value At 20 °C: 7.8
· Change in condition
Melting point/Melting range: Undetermined.
Boiling point/Boiling range: 130 °C
· Flash point: 55 °C (DIN 53213)
· Flammability (solid, gaseous): Not applicable.
· Ignition temperature: > 200 °C
· Decomposition temperature: Not determined.
· Self-igniting: Product is not selfigniting.
· Danger of explosion: Not determined.
· Explosion limits:
Lower: 0.6 Vol %
Upper: 7.0 Vol %
· Vapour pressure At 20 °C: 3 hPa
· Density At 20 °C: 0.86 g/cm³ (DIN 51757)
· Relative density Not determined.
· Vapour density Not determined.
· Evaporation rate Not determined.
· Solubility in / Miscibility with
water: Not miscible or difficult to mix.
· Partition coefficient (n-octanol/water): Not determined.
· Viscosity:
Dynamic: Not determined.
Kinematic: Not determined.
· Solvent content:
Organic solvents: 11.6 %
Solids content: 88.0 % (DIN 53216)
· 9.2 Other information No further relevant information available.
· VOC (EU): 11.56 %
· VOC (EU): 99.4 g/l
· VOCV: 11.56 %
GB
(Contd. on page 5)

40.1.0
 Page 5/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 26.02.2015 Version number 12 Revision: 16.01.2015

Trade name: DINITROL PASTA

(Contd. of page 4)

SECTION 10: Stability and reactivity

· 10.1 Reactivity
· 10.2 Chemical stability
· Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications.
· 10.3 Possibility of hazardous reactions No dangerous reactions known.
· 10.4 Conditions to avoid No further relevant information available.
· 10.5 Incompatible materials: No further relevant information available.
· 10.6 Hazardous decomposition products: Carbon monoxide

SECTION 11: Toxicological information

· 11.1 Information on toxicological effects
· Acute toxicity:
· LD/LC50 values relevant for classification:
ATE (Acute Toxicity Estimates)
Inhalative LC50/4 h 42904 mg/l
64742-48-9 Naphtha (petroleum), hydrotreated heavy
Oral LD50 >5000 mg/kg (RAT)
Dermal LD50 >5000 mg/kg (RABBIT)
Inhalative LC50/4 h > 4951 mg/l (RAT)
· Primary irritant effect:
· on the skin: No irritant effect.
· on the eye: No irritating effect.
· Sensitisation: No sensitising effects known.
· Additional toxicological information: No further relevant information available.

SECTION 12: Ecological information

· 12.1 Toxicity
· Aquatic toxicity: No further relevant information available.
· 12.2 Persistence and degradability No further relevant information available.
· 12.3 Bioaccumulative potential No further relevant information available.
· 12.4 Mobility in soil No further relevant information available.
· Additional ecological information:
· General notes:
Water hazard class 1 (German Regulation) (Self-assessment): slightly hazardous for water
Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage
system.
· 12.5 Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.
· 12.6 Other adverse effects No further relevant information available.

SECTION 13: Disposal considerations

· 13.1 Waste treatment methods
· Recommendation
Must not be disposed together with household garbage. Do not allow product to reach sewage system.
Dispose of as dangerous waste.
(Contd. on page 6)
GB

40.1.0
 Page 6/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 26.02.2015 Version number 12 Revision: 16.01.2015

Trade name: DINITROL PASTA

(Contd. of page 5)
· European waste catalogue
08 00 00 WASTES FROM THE MANUFACTURE, FORMULATION, SUPPLY AND USE (MFSU) OF
COATINGS (PAINTS, VARNISHES AND VITREOUS ENAMELS), ADHESIVES, SEALANTS
AND PRINTING INKS
08 01 00 wastes from MFSU and removal of paint and varnish
08 01 11* waste paint and varnish containing organic solvents or other dangerous substances
· Uncleaned packaging:
· Recommendation: Disposal must be made according to official regulations.

SECTION 14: Transport information

· 14.1 UN-Number
· ADR, IMDG, IATA UN1139
· 14.2 UN proper shipping name
· ADR 1139 COATING SOLUTION, special provision 640E
· IMDG, IATA COATING SOLUTION
· 14.3 Transport hazard class(es)
· ADR, IMDG, IATA

· Class 3 Flammable liquids.

· Label 3
· 14.4 Packing group
· ADR, IMDG, IATA III
· 14.5 Environmental hazards:
· Marine pollutant: No
· 14.6 Special precautions for user Warning: Flammable liquids.
· Danger code (Kemler): 30
· EMS Number: F-E,S-E
· 14.7 Transport in bulk according to Annex II of
MARPOL73/78 and the IBC Code Not applicable.
· Transport/Additional information:
· ADR
· Limited quantities (LQ) 5L
· Excepted quantities (EQ) Code: E1
Maximum net quantity per inner packaging: 30 ml
Maximum net quantity per outer packaging: 1000 ml
· Transport category 3
· Tunnel restriction code D/E
· IMDG
· Limited quantities (LQ) 5L
· Excepted quantities (EQ) Code: E1
Maximum net quantity per inner packaging: 30 ml
Maximum net quantity per outer packaging: 1000 ml
(Contd. on page 7)
GB

40.1.0
 Page 7/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 26.02.2015 Version number 12 Revision: 16.01.2015

Trade name: DINITROL PASTA

(Contd. of page 6)

· UN "Model Regulation": UN1139, COATING SOLUTION, special provision 640E,

3, III

SECTION 15: Regulatory information

· 15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
· Labelling according to Regulation (EC) No 1272/2008
The product is classified and labelled according to the CLP regulation.
· Hazard pictograms

GHS02

· Signal word Warning

· Hazard statements
H226 Flammable liquid and vapour.
· Precautionary statements
P210 Keep away from heat/sparks/open flames/hot surfaces. - No smoking.
P243 Take precautionary measures against static discharge.
P280 Wear protective gloves/protective clothing/eye protection.
P303+P361+P353 IF ON SKIN (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin
with water/shower.
P403+P235 Store in a well-ventilated place. Keep cool.
P501 Dispose of contents/container in accordance with local/regional/national/international
regulations.
· National regulations:
· Technical instructions (air):
Class Share in %
NK 11.6

· Waterhazard class: Water hazard class 1 (Self-assessment): slightly hazardous for water.
· 15.2 Chemical safety assessment: A Chemical Safety Assessment has not been carried out.

SECTION 16: Other information

This information is based on our present knowledge. However, this shall not constitute a guarantee for any
specific product features and shall not establish a legally valid contractual relationship.
· Relevant phrases
H226 Flammable liquid and vapour.
H304 May be fatal if swallowed and enters airways.
H336 May cause drowsiness or dizziness.
R10 Flammable.
R65 Harmful: may cause lung damage if swallowed.
R66 Repeated exposure may cause skin dryness or cracking.
R67 Vapours may cause drowsiness and dizziness.
· Department issuing MSDS: Research & Development
· Contact: Kontakt: [email protected] oder Tel.: 0049 (0)5281 982 980
· Abbreviations and acronyms:
RID: Règlement international concernant le transport des marchandises dangereuses par chemin de fer (Regulations Concerning the
International Transport of Dangerous Goods by Rail)
ICAO: International Civil Aviation Organisation
(Contd. on page 8)
GB

40.1.0
 Page 8/8
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 26.02.2015 Version number 12 Revision: 16.01.2015

Trade name: DINITROL PASTA

(Contd. of page 7)
ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International
Carriage of Dangerous Goods by Road)
IMDG: International Maritime Code for Dangerous Goods
IATA: International Air Transport Association
GHS: Globally Harmonised System of Classification and Labelling of Chemicals
EINECS: European Inventory of Existing Commercial Chemical Substances
ELINCS: European List of Notified Chemical Substances
CAS: Chemical Abstracts Service (division of the American Chemical Society)
DNEL: Derived No-Effect Level (REACH)
LC50: Lethal concentration, 50 percent
LD50: Lethal dose, 50 percent
Flam. Liq. 3: Flammable liquids, Hazard Category 3
STOT SE 3: Specific target organ toxicity - Single exposure, Hazard Category 3
Asp. Tox. 1: Aspiration hazard, Hazard Category 1
GB

40.1.0